2019 CHEVROLET 5500HD Problems

Complaints Reported

Complaints by Component

SERVICE BRAKES, HYDRAULIC

1 complaint

The contact owns a 2019 Chevrolet Silverado 6500 Commercial Vehicle. The contact stated that the recall repair of NHTSA Campaign Number: 23V266000 (Service Brakes, Hydraulic) was previously performed on the vehicle. The contact stated while the driver was driving 55-60 MPH uphill, he noticed smoke coming from underneath the driver's side of the hood. The contact stated that the driver depressed the brake pedal several times, but the brake pedal went down to the floorboard, and the vehicle failed to respond. The driver veered to the side of the road and allowed the vehicle to roll to a stop. The messages "Engine Power Reduced" and "Service Emission System" were displayed. The driver exited the vehicle and noticed that there was fire coming from underneath the driver's side of the hood, by the firewall. The driver attempted to extinguish the fire with a fire extinguisher but was unable to. The fire was extinguished by the fire department. A fire department report and a police report were not filed. The driver did not sustain any injuries. The contact stated that the vehicle burned to the ground from the front end to the cabin of the vehicle. Additionally, the contact stated that the fire had extended to the flatbed. The vehicle was towed to the company's location. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 180,000.

May 02, 2024

Fire: 1

FUEL/PROPULSION SYSTEM

1 complaint

Sudden catastrophic fuel system failure due to contamination fuel and fuel filter bypass, yes it is available to inspect. Truck shut off during operations and did not restart, the vehicle is at the dealership to replace High pressure fuel pump, lines, fuel rail and injectors. After the the truck died there was a message in the message center "water in fuel, service". The truck never sputtered, no loss of power or engine light. No codes were thrown either.

Apr 10, 2024

ENGINE

1 complaint

WATER LINE CRACKING LEAKING ANTIFREEZE OVERHEATING ENGINE

Nov 12, 2020

POWER TRAIN

1 complaint

WHEN DRIVING, IT FEELS LIKE IM RIDING ON RUMBLE STRIPS. TRANSMISSION FEELS LIKE ITS SLIPPING WHEN DRIVING AT LOWER SPEEDS AND WHEN ON THROTTLE, LIKE GOING UP HILL. DO NOT NOTICE A DIFFERENCE IN 4X4 MODE. TRUCK ALSO HAS HARD SHIFTING FROM 1-2 AND 2-3RD GEAR.

Oct 27, 2020

ELECTRICAL SYSTEM,SERVICE BRAKES,FUEL/PROPULSION SYSTEM

1 complaint

MY TRUCK WILL STOP RUNNING AT FREEWAY SPEEDS WITH NO ENGIN LIGHT HAVE HAD TO STOP IN TRAVEL LANE TO RESTART THE TRUCK THE BRAKES WILL SHAKE STEERING WHEEL OUT OF YOUR HANDS AND MUTIPUL EMISSION RELATED ENGIN LIGHTS DAILY THE TRUCK IS ONLY 3 WEEKS OLD THE ENGIN BRAKE SHIFTS FROM OVER DRIVE TO 3RD OR SECOND GEAR REDLINING THE MOTOR AND U HAVE TO APPLY WIDE OPEN THEOTTLE WHILE PULLING A TRAILER DOWN A STEEP GRADE VERY UNSAFE

Aug 14, 2020

SERVICE BRAKES

1 complaint

BRAKE BOOSTER PUMP MOTOR RUNS ALL THE TIME EVEN AFTER IGNITION IS TURNED OFF. IF TRUCK WAS TO SHUT OFF THEN WOULD HAVE NO BRAKES TO STOP,

Feb 11, 2020

⭐

4.3/5.0

54 reviews

Frequently Asked Questions

How many problems does the 2019 CHEVROLET 5500HD have?

The 2019 CHEVROLET 5500HD currently has 6 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2019 CHEVROLET 5500HD?

The most common problems reported for the 2019 CHEVROLET 5500HD are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2019 CHEVROLET 5500HD problem data come from?

All problem and complaint data for the 2019 CHEVROLET 5500HD comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.