2004 CHEVROLET Corvette Problems & Complaints
Real owner complaints and problems reported to the National Highway Traffic Safety Administration (NHTSA). View common issues by component.
217
Complaints Reported
Complaints by Component
FUEL SYSTEM, GASOLINE
91 complaints
The contact owns a 2004 Chevrolet Corvette. The contact stated while driving approximately 35 MPH, the odor of gasoline was detected by the contact and his wife. The contact stated no warning light was illuminated. The contact stated that the odor of gasoline was strongest in the cabin after refueling the vehicle to a full tank. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that a cross fill tube needed to be installed. The vehicle had been repaired. The contact stated that the gasoline odor was again detected while driving at various speeds. The contact researched online and related the failure to NHTSA Action Number: PE10015 (Fuel System, Gasoline). The manufacturer had not been informed of the failure. The failure mileage was approximately 44,000.
Aug 07, 2023
The contact owns a 2004 Chevrolet Corvette. The contact stated while driving at slow speeds and approaching a stop, an abnormal odor of fuel was detected. The contact noticed there was fuel leaking in the garage. The vehicle was taken to the local dealer where it was diagnosed that the fuel tank and crossover tube cross connector needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but no additional assistance was provided. The contact stated the failure was related to NHTSA Action Number: PE10015 (Fuel System, Gasoline). The approximate failure mileage was 41,000. The contact stated that the vehicle was repaired and is seeking reimbursement from the manufacturer for the cost.
Aug 22, 2022
THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. THE CONTACT STATED WHILE DRIVING 35 MPH, THE CONTACT SMELLED AN ABNORMAL FUEL ODOR COMING FROM THE ENGINE COMPARTMENT. THERE WAS NO WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO THE LOCAL DEALER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FUEL TANK CROSSOVER PIPE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT YET REPAIRED. THE CONTACT RELATED THE ISSUE TO AN UNKNOWN MANUFACTURER’S RECALL. THE MANUFACTURER WAS INFORMED OF THE FAILURE BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 36,000.
May 18, 2021
SINCE BUYING THIS CAR AT AUCTION. I NOTICED A FUEL SMELL COMING FROM LEFT REAR WHEELS. I HAVE ASKED THE DEALERSHIP IF THERE WERE ANY RECALLS OR SPECIALS ANNOUNCEMENTS DEALING WITH CAR AND WAS TOLD NO. AFTER READING THE CORVETTE FORUM AND FINDING THERE WAS A REPAIR FOR THE FUEL TANK. NOW MY CAR IS OUT OF THE COVERAGE TIME FRAME AND MILEAGE HOWEVER WITH THE TANK BEING DEFECTIVE SHOULDN'T THEY AT LEAST COVER THE TANK. OR WHAT WAS THE AGREEMENT BETWEEN NHTSA AND CHEVROLET. *TR
Jul 09, 2014
I FILLED MY TANK TODAY WITH NO OVER FLOW OF GAS. I GOT IN MY VEHICLE AND STARTED THE CAR. I NOW HAVE A VERY STRONG GASOLINE SMELL. IT IS ALL THROUGHOUT THE CABIN AND MAKE GAS APPEARS TO BE RUNNING OUT FASTER THAN NORMAL. I PARK IN A GARAGE WHICH HAS A GAS WATER HEATER IN IT. I AM VERY CONCERNED THAT THE HOUSE COULD CATCH ON FIRE IF THE LEAK GETS STRONGER. *TR
Mar 24, 2014
+ 86 more complaints for this component
FUEL/PROPULSION SYSTEM
49 complaints
- Fuel tank leaks - gasoline puddles under car, heavy fumes - Fire / explosion hazard - Confirmed by local mechanic as existing problem in that year - Inspected and confirmed by selling dealer - trying to repair - No auto warning, smell of fumes and gas on garage floor day after delivery of car
Aug 01, 2024
A month after I purchased the car with approximately 40k miles, I took the car in for an oil change at the dealership and was told there was a major leak in the left fuel tank and at the crossover tube. This leaking fuel is leaking onto the exhaust. It would cost at least $4,000 to repair. I can not afford this. It is too dangerous to drive. I have no other car. Supposedly, my vin number is 200 numbers away from being included in the recall for the same issue and that you have 43 pages of complaints about. Did I mention that the crossover tube is a backordered part because so many are needed because when you pull the current one out, it breaks and a new one is needed?
Nov 24, 2023
Fuel tank leaking/fumes. Appeara to be crossover tube connection connecting the 2 tanks.
Sep 04, 2023
In 2011 Chevrolet acknowledged an issue with the fuel system as the the attached letter states. I was not the owner of the vehicle in 2011 and since the issue was not elevated to an official recall it did not show up on the car fax report and I thus was unaware of this potential safety hazard. My car has now developed all the symptoms of the fuel tank leak with fumes in the car and gas dripping on the garage floor when parked. Although my car only has 30,000 miles the end date for GM to provide repair was August 11, 2011. The significant risk to passengers, the car, and my home when the car is parked in the attached garage is unacceptable as caused by a faulty engineered fuel modification in this model year. The fuel leak is both a safety and environmental risk and should warrant a recall and GM to mitigate the costs. Their liability for a faulty engineered system should not have a time limit.
Apr 05, 2023
Purchased the vehicle in 2015. That same purchased date I filled the vehicle with fuel. The following day my garage was totally covered with gas fumes. No tech could find the problem. On Feb 22 2023 while filling up, gas was pouring out the bottom left side . This is very dangerous. Come to find out that many others have had the same problem. There is a manufacturer defect of the gas tank housing tube . I cannot drive the vehicle because it’s to dangerous and to costly to repair.
Mar 13, 2023
+ 44 more complaints for this component
STEERING
25 complaints
The contact's friend owns a 2004 Chevrolet Corvette. The contact stated that while his friend was starting the vehicle, the steering wheel seized. The dealer was made aware of the failure but informed the contact that they were unable to assist due to the age of the vehicle. The vehicle was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Campaign Number: 04V060000 (Steering) however, the VIN was not included in the recall. The failure mileage was approximately 75,000.
Aug 01, 2022
TL* THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE STEERING COLUMN WAS MALFUNCTIONING. THE LOCKING PIN FOR THE ANTI-THEFT DEVICE FOR THE STEERING COLUMN WAS NOT WORKING AND STOPPED THE VEHICLE FROM MOVING. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THERE WERE NO RECALLS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 33,200.
Aug 08, 2019
TL* THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. WHILE DRIVING 35 MPH, THE STEERING WHEEL SEIZED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO GALLES CHEVROLET (2801 UNIVERSITY BLVD NE, ALBUQUERQUE, MN 87107) WHERE IT WAS DIAGNOSED THAT THE STEERING COLUMN NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER INFORMED THE CONTACT THAT THERE WERE NO RECALLS AND THE VEHICLE WAS NOT UNDER WARRANTY. THE FAILURE MILEAGE WAS APPROXIMATELY 89,000. THE VIN WAS NOT AVAILABLE.
Jun 12, 2018
TL* THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. WHILE ATTEMPTING TO RESTART THE VEHICLE, THE ENGINE SHUT OFF AND A "SERVICE STEERING COLUMN" MESSAGE DISPLAYED. THE VEHICLE CONTINUED TO STALL. THE CONTACT ALSO OBSERVED A SECOND MESSAGE THAT READ "TAKE THE KEY OUT FOR 10 SECOND AND REINSERT". AFTER FOLLOWING THE INSTRUCTIONS, THE VEHICLE OPERATED NORMALLY. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE DEALER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V06000 (STEERING), ALTHOUGH THE FAILURES WERE IDENTICAL. THE FAILURE MILEAGE WAS 6,100.
Sep 06, 2016
THE VEHICLE'S ELECTRONIC COLUMN LOCKING SYSTEM WAS HAVING INTERMITTENT SEVERE FAILURE. WHEN TRYING TO STEER THE CAR AFTER IGNITION AND MOVING DOWN THE ROAD THE WHEEL WOULD LOCK IN CERTAIN POSITIONS AND TO PREVENT A CRASH I WOULD HAVE TO STOP THE CAR AND HOPE THE LOCKING SYSTEM RELEASED. I FOUND THAT THIS ISSUE WAS COVERED BY #04006C PRODUCT SAFETY RECALL. WHEN I CONTACTED THE SERVICE DEPARTMENT AT NUCAR CHEVROLET; THEY INDICATED THAT THE RECALL WAS NOT STILL OPEN. THUS I WAS FORCED TO HAVE MY MECHANIC REPAIR THIS BEFORE A SERIOUS CRASH OCCURRED. I ALSO CALLED THE CHEVROLET PRODUCT RECALL LINE AND WAS TOLD THAT MY VEHICLE WAS NOT ONE OF THE AFFECTED VIN'S. THAT IS NOT THE CASE IF YOU REVIEW DOCUMENT ID#1761087 OR THE ATTACHED DOCUMENTATION I HAVE FOUND. ON 8/24/16 I PAID $215.46 PLUS MY TIME AND TALENT TO RESEARCH AND BRING THIS FORWARD. I BELIEVE GM NEEDS TO REIMBURSE ME FOR THIS ISSUE. PLEASE ADVISE HOW BEST TO PROCEED. THANK YOU *JS *JS
Aug 26, 2016
+ 20 more complaints for this component
ELECTRICAL SYSTEM
4 complaints
TL* THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. WHILE DRIVING, THE SERVICE COLUMN LOCK INDICATOR ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO CASEY CHEVROLET (11700 JEFFERSON AVE, NEWPORT NEWS, VA 23606, (757) 320-1476), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 68,000.
Nov 25, 2019
TL* THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. THE CONTACT STATED THAT WHILE DRIVING AT 20 MPH, THE SERVICE ACTIVE HANDLING SYSTEM WARNING MESSAGE ILLUMINATED. IN ADDITION, THE CONTACT STATED THAT WARNING CHIME FAILED TO OPERATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE THERMOSTAT, SERPENTINE BELT AND TENSIONER BELT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 74,000.
Jan 18, 2017
I WAS DRIVING ON A HIGHWAY AT 65MPH IN A BUMPY CONSTRUCTION ZONE. ALL OF A SUDDEN, WITHOUT WARNING, THE ENGINE COMPLETELY SHUT DOWN. I WAS ABLE TO STEER THE CAR OFF TO THE SHOULDER OF THE ROAD. AFTER LETTING THE CAR SIT FOR A MINUTE, I WAS ABLE TO RESTART THE CAR AND IMMEDIATELY DROVE IT BACK HOME ON A SURFACE STREET AND TOOK IT TO THE DEALER THE NEXT DAY. THE DEALER PUT IT ON THE SCOPE AND COULD FIND NO PROBLEMS WITH THE CAR. THE ONLY THING I COULD THINK OF WAS THAT I HAD A MEDALLION ON THE KEY RING AND THE SERVICE MANAGER ADVISED ME TO ONLY KEEP THE IGNITION KEY ON THE RING BECAUSE THE SWAYING OF THE KEY CHAIN MAY HAVE AFFECTED THE IGNITION SWITCH AND TURNED OFF THE ENGINE. BASED ON THE RECENT INFO ON KEYS SWAYING AND CUTTING OFF THE IGNITION TO THE CAR, I WAS WONDERING IF IT AFFECTED THE CORVETTE MODELS ALSO. I ONLY KEEP THE IGNITION KEY ON THE KEY RING AND HAVEN'T HAD A PROBLEM SINCE THAT TIME. *TR
Mar 17, 2014
1) I RECEIVED A RECALL NOTICE FROM CHEVROLET RECALL INFORMATION PROCESSING CENTER ON MAY 13, 2004. THE RECALL IS # 04006 - ELECTRONIC COLUMN LOCK SYSTEM. THIS RECALL WAS STARTED ON FEB. 9, 2004 ACCORDING TO YOUR SITE. 2) I PURCHASE THE 2004 CHEVROLET CORVETTE COUP ON SEPTEMBER 9, 2004. I QUESTION CHEVROLET'S COMMITMENT TO SAFETY. ISSUEING A RECALL IN FEB. OF 2004 AND NOT BOTHERING TO REPAIR THE DEFECT WELL THE CAR WAS IN THEIR TOTAL CONTROL FOR 8 MONTHS, THEN SELLING ME THE CAR KNOWING FULL WELL THE DEFECT HAD NOT BE FIX, THEN WAITING ANOTHER 9 MONTHS TO NOTIFY ME. I CONTACED THE DEALER ON MAY 16, 2005, TO SEE IF THE CAR HAD THE RECALL DEFECT REPAIRED. IT HAD NOT. SO CHEVROLET HAS WAITED A TOTAL OF 17 MONTHS. NOT EXACTLY A CONSUMER ADVOCATE FOR SAFETY TO THE DRIVING PUBLIC. 3)ACCORDING TO THE DEALER, THIS WORK CAN ONLY BE DONE DURING THE WEEK, NOT A WEEKEND. SO NOW, I HAVE TO MISS A DAY OF WORK FOR A PROBLEM THAT SHOULD HAVE BEEN TAKEN CARE OF BEFORE I EVEN PURCHASED THE CAR. NOW I KNOW WHY CHEVROLET ALWAYS SENDS OUT A SATIFSFACTION QUESTIONAIRE 30 DAYS AFTER PURCHASE, BECAUSE THEY KNOW MOST OF THEIR VEHICLES SHOULD LAST THAT LONG. I'M SURE I WILL NOT GET ONE AFTER A YEAR HAS PASTED.
May 16, 2005
STEERING,ELECTRICAL SYSTEM
3 complaints
When I start my vehicle, the steering wheel locking system does not disengage and the steering wheel stays locked.
Apr 17, 2024
TL* THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. WHILE THE VEHICLE WAS PARKED OUTSIDE THE GARAGE AND THE IGNITION WAS STARTED, THE CLUTCH WAS RELEASED AND THE VEHICLE SEIZED. ALSO, THE STEERING COLUMN LOCK WARNING MESSAGE ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING). THE VEHICLE WAS NOT ABLE TO BE DRIVEN. THE CONTACT CALLED MAGUIRE CHEVROLET CADILLAC OF ITHACA (LOCATED AT 35 CINEMA DR, ITHACA, NY 14850, (607) 272-9292) AND NOTIFIED THEM OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 6,890. *TR
Oct 07, 2019
I WAS DRIVING SOUTH, ON I-25, IN ALBUQUERQUE, NM, WHEN I BUMPED THE IGNITION KEY WITH MY HAND AND THE ENGINE SHUT OFF. THIS OCCURRED A COUPLE OF MORE TIMES SINCE THEN. WHEN I HEARD OF THIS HAPPENING WITH OTHER CHEVROLETS, I CALLED A DEALER, IN ALBUQUERQUE, REPORTED THAT IT HAD ALSO HAPPENED IN MY 2004 CORVETTE C5. THE SERVICE MANAGER TOLD ME THERE WERE NO RECALLS, ORDERS, OR TECH ORDERS FOR THAT MODEL CAR. HAVE OTHER OCCURRENCES BEEN REPORTED? I HAVEN'T SEEN ANY ON THE CORVETTE BLOGS. *TR
Mar 14, 2014
ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES
3 complaints
AFTER TELESCOPING STEERING WHEEL, ACTIVE HANDLING SYSTEM WARNING LIGHT CAME ON AND WHILE DRIVING CAR PULLED LEFT INTO ONCOMING TRAFFIC LANE
Feb 10, 2020
WHEN BRAKES ARE APPLIED THEY START TO CATCH AND A GRINDING, CHATTERING IS FELT IN THE BRAKES UNTIL I LET UP OFF THE PEDAL. THE ACTIVE HANDLING CODE APPEARS AND THEN GOES AWAY. ON SEVERAL OCCASIONS THE ACTIVE HANDLING CODE APPEARS AND WILL NOT GO AWAY UNTIL THE VEHICLE IS SWITCHED OFF ANF THEN RESTARTED. *TR
Sep 15, 2014
AS I WAS DRIVING THE SERVICE ACTIVE HANDLING MESSAGE CAME ON THE DIC.THEN THE CAR BRAKES ENGAGED PULLING THE CAR TO THE LEFT. *JS
Jul 29, 2014
VISIBILITY
3 complaints
IN OCTOBER OF 2005 THE DRIVER SIDE POWER WINDOW CEASED TO FUNCTION, AND THE PASSENGER SIDE OPERATED SPORADICALLY. DEALER REPLACED BOTH WINDOW REGULATORS UNDER WARRANTY. THEN IN FEBRUARY OF 2007, THE PASSENGER WINDOW CEASED TO FUNCTION AGAIN. ONCE AGAIN THIS REGULATOR WAS REPLACED UNDER WARRANTY. THEN IN FEBRUARY 2010 THE PASSENGER WINDOWS CEASED TO OPERATE AGAIN, THEN MAY 2010 THE DRIVER SIDE WINDOW CEASED TO OPERATE AGAIN. THE DEALER REPLACED THESE NOW AT A VERY SIGNIFICANT FEE (2.5% THE ORIGINAL COST OF THE VEHICLE). THEREFORE IN 6 YEARS I WENT THROUGH 7 WINDOW REGULATORS, AND HAVE TALKED TO OTHER OWNERS OF THE SAME VEHICLE THAT HAVE HAD THE SAME EXPERIENCE. THE ODD PART IS THAT I RARELY ROLL EITHER WINDOW DOWN. *TR
Nov 22, 2013
2004 CHEVROLET CORVETTE POWER WINDOW REGULATORS KEEP FAILING. WINDOW WILL EITHER NOT ROLL DOWN AT ALL, OR SOMETIMES THE REGULATOR CABLE WILL FRAY AND WINDOW WILL PARTIALLY GO DOWN. I HAVE HAD TWO REGULATORS ON THE PASSENGER SIDE AND THE CURRENT ONE NO LONGER WORKS. AND I HAVE JUST INSTALLED THE THIRD ONE ON THE DRIVER SIDE. THIS CAR ONLY HAS 48,000 MILE ON IT AND IT IS BABIED. YET THESE PARTS KEEP FAILING AND THE REPAIR COST IS $550.00 PER INCIDENT. 5 REGULATORS IN UNDER 50,000 MILES SEEMS LIKE A PROBLEM TO ME SINCE I HAVE OWNED 20 CARS IN MY LIFE AND HAVE NEVER HAD THIS PROBLEM UNTIL NOW. *TR
Aug 19, 2011
THERE WAS NO NOTICEABLE REASON FOR THE PASSENGER WINDOW TO FAIL. I DON'T HAVE CHILDREN THAT WOULD HAVE BEEN PLAYING WITH THE WINDOWS TO HAVE CAUSED THE FAILURE. THE PASSENGER WINDOW REGULATOR OR ASSOCIATED PARTS JUST CEASED WORKING. IN FACT I USE THE DRIVER'S SIDE WINDOW 5 TIMES AS OFTEN AS THE PASSENGER WINDOW, AND I HAVE NEVER HAD A PROBLEM. THE FIRST TIME WAS IN 2005, AND A FEW DAYS AGO ON 5-18-07. *AK
May 21, 2007
SERVICE BRAKES
2 complaints
THE EBCM DOES NOT WORK I'VE TRIED TO HAVE IT REPAIRED 3 TIMES NOW TOLD UNREPAIRABLE GM NO LONGER MAKES THE PART WITH SO MANY VETTE OWNERS HAVING THIS PROBLEM YOU WOULD WONDER WHY THERE ISN'T SOMETHING BEING DONE CAUSE NOW WE ARE DRIVING VEHICLE NOT THE WAY IT WAS INTENDED SPOKE TO GM MANY TIMES PRETTY TOLD DISCONTINUED SORRY TOO BAD YOUR ON YOUR OWN
Dec 10, 2019
TL* THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS THE BRAKES LOCKED. IMMEDIATELY AFTER THE BRAKES LOCKED HE NOTICED A WARNING LIGHT THAT STATED SERVICE ACTION HANDLING. THE VEHICLE WAS TAKEN TO THE DEALER; HOWEVER, THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 13,600. THE CURRENT MILEAGE WAS APPROXIMATELY 13,700. THE VIN WAS UNAVAILABLE. *TR
Mar 22, 2013
ELECTRONIC STABILITY CONTROL (ESC),TRACTION CONTROL SYSTEM
2 complaints
ELECTRONIC STABILITY CONTROL, TRACTION CONTROL SYSTEM AT DIFFERENT SPEEDS MY TRACTION CONTROL WARNING LIGHT COMES ON FOR NO REASON, AND THE VEHICLE FEELS LIKE ITS TRYING TO ENGAGE THE ABS SYSTEM. IT NOW COMES ON JUST ABUT EVERYTIME I GET I DRIVE MY VEHICLE. I HAVE SINCE LEARNED THAT THIS IS HAPPENING TO THOUSANDS OF CORVETTES AT AN ALARMING RATE. *TR
Apr 12, 2013
AT DIFFERENT SPEEDS MY TRACTION CONTROL WARNING LIGHT COMES ON FOR NO REASON, AND THE VEHICLE FEELS LIKE ITS TRYING TO ENGAGE THE ABS SYSTEM. IT NOW COMES ON JUST ABUT EVERYTIME I GET I DRIVE MY VEHICLE. I HAVE SINCE LEARNED THAT THIS IS HAPPENING TO THOUSANDS OF CORVETTES AT AN ALARMING RATE. *TR
Mar 14, 2013
ENGINE AND ENGINE COOLING
2 complaints
TL*THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. WHILE STARTING THE VEHICLE, THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN EMISSIONS STATIONS AND THE CONTACT WAS INFORMED THAT THE SECONDARY AIR DUCT ION SYSTEM WAS THE CAUSE OF FAILURE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE DEALER CONFIRMED THAT THE AIR DUCT SYSTEM WAS THE CAUSE. THE CONTACT PAID FOR THE REPAIRS BUT THE CHECK ENGINE LIGHT ILLUMINATED AGAIN. IT HAD NOT BEEN REPAIRED AGAIN AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS 18,550. THE CURRENT MILEAGE WAS 18,600. UPDATED 08/17/10. *LJ THE CONSUMER STATED HE EXPERIENCED EMISSIONS FAILURE FOR THE SECOND TIME. UPDATED 08/23/10*JB
Jun 02, 2010
ENGINE OIL LEAK L/H FRONT OF OIL PAN LEAKING OIL. GM VOIDED WARRANTY. *NM
Dec 06, 2005
STRUCTURE
2 complaints
I HAVE A 2000 CHEVROLET CORVETTE AND A 2004 CHEVROLET COMMEMORATIVE EDITION CORVETTE. BOTH OF MY VETTES HAVE HAD A ROOF LEAK AND BOTH CARS HAVE THE FIXED ROOF. NEITHER VEHICLES HAVE EVER BEEN WRECKED. IT HAS CAUSED MILDEW ON THE HEADLINER AS WELL AS NUMEROUS PROBLEMS WITH WIRING IN THE CAR DUE TO THE LEAK. BECAUSE MY 2000 CORVETTE HAD NO WARRANTY WE FIXED THE PROBLEM OURSELVES, BUT MY 2004 CORVETTE STILL IS HAVING A PROBLEM. I TOOK IT TO THE DEALERSHIP BECAUSE IT IS UNDER WARRANTY BUT THE WARRANTY WOULD NOT COVER THE ROOF LEAK. I WAS WONDERING IF THERE HAVE BEEN OTHER PEOPLE HAVING THE SAME PROBLEM. IT SEEMS TO COINCIDENTAL TO HAVE THE PROBLEM ON TWO CORVETTES. *TR
Dec 30, 2009
TL*THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. THE REMOVABLE TOP ON THE VEHICLE WAS LOOSE. WHILE DRIVING OVER A BUMP AT ANY SPEED, THE TOP SOUNDS AS IF IT WILL DETACH FROM THE VEHICLE. THE DEALER STATED THAT THERE WAS NO SAFETY RECALL ON THE REMOVABLE TOP. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 8,100.
Apr 29, 2008
POWER TRAIN
2 complaints
SHIFTER POPS-OUT OF REVERSE WHEN FULLY ENGAGED IN REVERSE THE SHIFTER POPS OUT. THIS A KNOWN PROBLEM AND HAS TO DO WITH THE TRANSMISSION AND NOT THE SHIFTER, ALTHOUGH IT IS SLOPPY ALSO. *NM
Dec 06, 2005
CLUTCH WOULD NOT DISENGAGE AFTER HIGH OR LOW RPM THE CLUTCH REMAINED ENGAGED. WAS ABLE TO WORK IT LOOSE AFTER RECYLING THE CLUTCH PEDAL. *NM
Dec 06, 2005
ELECTRICAL SYSTEM,ENGINE
1 complaint
The contact owns a 2004 Chevrolet Corvette. The contact stated while driving, the vehicle failed to move farther than five feet before the vehicle stalled and lost motive power. The pull-out key and wait-ten-seconds message were displayed. The contact had to release the key from the ignition and restart the vehicle. The contact called an independent mechanic and was unable to determine the cause of the failure. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified about the failure. The failure mileage was approximately 30,000.
Dec 15, 2023
UNKNOWN OR OTHER
1 complaint
Strong Fuel smell near the fuel filler when car is parked in the garage.
Nov 05, 2023
STEERING,FORWARD COLLISION AVOIDANCE
1 complaint
WHILE TRAVELING DOWN THE FREEWAY AT AROUND 80 MPH ON A STRAIGHT FLAT SURFACE, THE CORVETTE SHARPLY VEERED TO THE SIDE AS I HEARD A LOUD SCREECH FROM ONE OF THE BRAKES IT LASTED FOR ABOUT A SECOND. THE TURN WAS SO ABRUPT I THOUGHT I WAS GOING TO ROLL BUT AFTER FISHTAILING WAS ABLE TO GET THINGS GOING STRAIGHT. IMMEDIATELY A SERVICE ACTIVE HANDLING SYSTEM MESSAGE POPPED UP. HAPPENED ABOUT A WEEK LATER GOING ABOUT 60 MPH NOT QUITE AS ABRUPT. THIS CONDITION COULD HAVE LEAD TO A FATALITY.
Mar 22, 2021
UNKNOWN OR OTHER,ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES
1 complaint
WHEN USING TELESCOPING STEERING WHEEL THE ACTIVE HANDLING LIGHT A CAME ON AND THE CAR PULLED HARD TO THE LEFT INTO ONCOMING TRAFFIC LANE WHILE DRIVING . I HAD NEVER USED THE TELESCOPING STERLING WHEEL FEATURE PRIOR TO THIS .*DT*JB
Feb 23, 2020
STEERING,SUSPENSION,EXTERIOR LIGHTING
1 complaint
PREPURCHASE RECALL SEARCH.
Nov 05, 2019
STEERING,AIR BAGS,FUEL/PROPULSION SYSTEM
1 complaint
TAKATA RECALL VISIBLE GASOLINE LEAKAGE AFTER VEHICLE HASN'T BEEN PARKED OVER A PERIOD OF MONTHS. THEN I BEGAN TO TAKE NOTES OF WHAT , WHEN , WHERE THIS LEAK WAS OCCURRING, I WOULD FILL THE TANK, PARK THE AUTO IN THE GARAGE . THE NEXT TIME I USED THE VEHICLE, A NOTICEABLE GAS ODOR, SPOT ON THE GARAGE FLOOR WAS NOTED. I STARTED TO PLACE A CARDBOARD UNDER THE FRONT END TO MORE READILY BE ABLE TO OBSERVE THE SUBSTANCE LEAKING. THE ODOR WAS UNMISTAKABLE. SEVERAL OCCURRENCES N SPOTTING IS EVIDENT AFTER HAVING PARKED IN MY GARAGE . THE AUTO WAS PARKED OVERNIGHT IN MY GARAGE. I AM LISTING THE LATEST CALENDAR DATE AND PHOTO. I HAVE OTHER DATES IN MY NOTEPAD. 2) MY SEATBELT OCCASIONALLY WILL NOT LOCK. I HEAR THE CLICK OF A SEATBELT LOCK THEN UPON DRIVING AWAY FROM MY HOME ~ ,25 MILES ~ MY SEATBELT UNLOCKED THROUGH NO FAULT OF MY OWN. 3) AIRBAG CANNOT BE CHECKED FOR EFFECTIVENESS .
Jun 20, 2018
WHEELS
1 complaint
CRACK ON REAR WHEEL POLISHED ALUMINUM ORIGINAL EQUIPMENT WHEEL LEAKING AIR FROM CRACK ON OUTER INNER RIM TPMS ALERTED ME TO LOSS OF AIR PRESSURE NEVER HIT A CURB. WHEEL SHOWS NO OTHER DAMAGE
Aug 04, 2017
STEERING,ENGINE,FUEL/PROPULSION SYSTEM
1 complaint
THIS REQUEST INVOLVES A SAFETY BULLETIN [#0400C6], DATED 2/8/2006 RELATING TO THE ELECTRONIC COLUMN LOCK (ECL) FOR APPROXIMATELY 96% OF ALL 220,000+ C-5 GENERATION CORVETTES. 2004 WAS THE LAST YEAR OF PRODUCTION FOR THE C-5 GENERATION. TOTAL PRODUCTION IN 2004 IS ESTIMATED TO HAVE BEEN ABOUT 35,000: OUT OF THIS, 20,861 VEHICLES WERE COVERED BY THE ABOVE SERVICE BULLETIN, BUT AS MINE WAS ASSEMBLED AFTER VIN #45120862 UNTIL ASSEMBLY BEGAN FOR THE 2005 MODEL YEAR (C-6 GENERATION), MY VIN NUMBER WAS NOT INCLUDED ON PAGE 2 OF THE BULLETIN. PRIOR TO THE STEERING COLUMN ON MY CAR LOCKING ON 6/28/2016 I HAD NOT BEEN MADE AWARE THAT THIS PERILOUS CONDITION EXISTED. GM HAS INDICATED THAT IT WILL NOT PROVIDE ANY FUNDS TO OFFSET THE COST OF REPAIRING THIS FAULT BECAUSE IT WAS NOT INCLUDED ON ANY SERVICE BULLETIN. I BELIEVE THAT SERVICE BULLETIN #04006C WAS INTENDED FOR (OR SHOULD APPLY TO) THE ENTIRE C-5 PRODUCTION -- UNLESS THERE IS SOME REASONABLE EXPLANATION AS TO WHY MY VEHICLE HAS BEEN EXCLUDED (SUCH AS A DIFFERENT ECL CONFIGURATION WAS USED, ETC.) IN EITHER EVENT, I FEEL THE COMPANY SHOULD HONOR MY REQUEST FOR A FULL REIMBURSEMENT FOR FUNDS EXPENDED TO REPLACE THE FAULTY ECL. I HAVE WRITTEN A LETTER TO GM EXPLAINING THE FACTS SURROUNDING THIS REQUEST AND HAVE ATTACHED A COPY OF THAT LETTER FOR YOUR REVIEW.
Jul 01, 2016
EXTERIOR LIGHTING
1 complaint
DRIVING ON A 4 LANE HIGHWAY, MY HEADLIGHTS WENT COMPLETELY DEAD AND WOULD NOT COME BACK ON. HAD TO PULL OFF THE HIGHWAY FOR APPROXIMATELY 5 MINUTES. THIS HAS HAPPENED 3 TIMES AFTER DARK. *TR
Feb 19, 2015
SERVICE BRAKES, HYDRAULIC,TRACTION CONTROL SYSTEM
1 complaint
CONSUMER WRITES IN REGARDS TO SAFETY ISSUES FOR 2002 AND 2004 CHEVROLET CORVETTES. *TGW THE CONSUMER STATED HE EXPERIENCED A FAILURE OF A MODULE WHICH CONTROLLED THE ABS AND TRACTION CONTROL SYSTEMS. *JB
Nov 13, 2014
STEERING,AIR BAGS
1 complaint
TL* THE CONTACT OWNS 2004 CHEVROLET CORVETTE. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE POWER STEERING FAILED CAUSING THE CONTACT TO CRASH. THE AIR BAGS FAILED TO DEPLOY AND THE VEHICLE TURNED OFF. A POLICE REPORT WAS FILED AND NO INJURIES WERE SUSTAINED. THE VEHICLE WAS TOTALED AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 92,900.
Sep 25, 2014
STEERING,VEHICLE SPEED CONTROL
1 complaint
GOING 80 ON FREEWAY CRUISE DISINGAGED ACTIVE HANDLING WARNING CAME ON CAR PULLED TO THE LEFT VERY SCARY CONTACTED CHEVOROLET NO HELP THERE ARE MANY MORE OF THESE SAME PROBLEMS REPORTED RECALL FOR 2005 FOR EXACT SAME PROBLEM. *TR
Mar 18, 2014
AIR BAGS
1 complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. THE CONTACT STATED THAT WHILE ENTERING THE DRIVER'S SIDE DOOR, SHE NOTICED THAT THE STEERING WHEEL AIR BAG COVER WAS MELTED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 12,000. THE VIN WAS UNAVAILABLE.
Dec 23, 2013
VEHICLE SPEED CONTROL,ELECTRONIC STABILITY CONTROL (ESC),TRACTION CONTROL SYSTEM
1 complaint
I WAS TRAVELING 70MPH ON A 4 LANE HWY. WHEN SUDDENLY MY BRAKES LOCKED UP FOR A SPLIT SECOND CAUSING ME TO VEER INTO THE LEFT LANE. I WAS ABLE TO RECOVER QUICKLY, HOWEVER IT COULD HAVE HAD SERIOUS CONSEQUENCES IF ANOTHER VEHICLE HAD BEEN ALONGSIDE ME. THE SERVICE ACTIVE HANDLING MESSAGE APPEARED ON MY DASH DISENGAGING THE ACTIVE HANDLING AND APPARENTLY THE TRACTION CONTROL SYSTEM. THE MESSAGE STAYED ON THE REMAINDER OF THE TRIP. THE NEXT DAY THE MESSAGE WAS GONE APPARENTLY RESETTING ITSELF. BECAUSE OF THE DANGEROUS SITUATION I TOOK THE CAR TO THE LOCAL CHEV. DEALERSHIP (LEN DUDAS MOTORS, STEVENS POINT, WI) HOWEVER THEY WERE NOT ABLE TO DETERMINE THE CAUSE. THE SENSORS TESTED NORMAL AND THE MECHANIC THEORIZED THE YAW RATE SENSOR BRACKET WAS AT FAULT, BUT HE WAS UNABLE TO FIND A PART. DURING THE PAST WEEK THE PROBLEM RESURFACED 2 MORE TIMES. I'VE RESEARCHED CORVETTE FORUMS ONLINE AND IT APPEARS THAT THIS IS A PROBLEM WITH CORVETTES AND THERE APPEARS TO BE MANY OPINIONS ON HOW TO FIX THE PROBLEM, MOST OF WHICH I DON'T UNDERSTAND BECAUSE I AM NOT A MECHANIC. ALSO IF MY LOCAL CHEVROLET MECHANIC CANNOT FIX THE PROBLEM WHAT CAN I DO. RIGHT NOW I CAN'T DRIVE THE VEHICLE FOR FEAR OF CAUSING AN ACCIDENT. *TR
Sep 30, 2013
STEERING,VEHICLE SPEED CONTROL,SERVICE BRAKES
1 complaint
WHILE DRIVING MY 2004 CORVETTE THE ACTIVE HANDLING MESSAGE COME ON AT THE DASH AND WHILE DRIVING THIS CAUSES THE BRAKES TO PULL THE CAR FROM ONE SIDE OR THE OTHER SUDDENLY AND THIS HAPPENS VERY OFTEN. I AM AFRAID THIS COULD CAUSE THE CAR TO HAVE A SERIOUS ACCIDENT. *TR
Jun 29, 2013
VEHICLE SPEED CONTROL,TRACTION CONTROL SYSTEM
1 complaint
2004 CHEVROLET CORVETTE. CONSUMER WRITES IN REGARDS TO MALFUNCTION OF CRUISE AND TRACTION CONTROLS. *SMD THE CONSUMER STATED OVER THE PAST TWO MONTHS THE CRUISE CONTROL WOULD SHUT OFF AUTOMATICALLY. HE WOULD TURN IT BACK ON AND IT WOULD WORK FOR A VERY SHORT TIME AND THEN SHUT OFF AGAIN. IN ADDITION, WHILE DRIVING AT A HIGH SPEEDS OF 65-70, THE CONSUMER FELT A SLIGHT SLOW DOWN IN THE ENGINE AND A PULL TO THE RIGHT IN THE STEERING. ONCE HE TURNED OFF THE TRACTION CONTROL, THE PROBLEM CEASED. *JB
Nov 19, 2012
ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM
1 complaint
DRIVING 65 MPH ON INTERSTATE 90 WISCONSIN. CAR JUST DIED,COULD NOT GET TO RESTART. 1 HOUR ON THE SIDE THE ROAD. CARS FLYING INCHES FROM US. POLICE OFFICER FINALLY STOPED AND CALLED TOW TRUCK AND STAYED BEHIND US WITH LIGHTS ON SO WE WOULDNT GET HIT. TO FIND OUT THIS IS A COMMON PROBLEM ON LOW MILAGE CORVETTES. SHOULD BE A RECALL BECAUSE THE CHEVY DEALER IN MIDDELTON WIS DIDNT KNOW WHAT WAS WRONG, IT KEEPS ON BLOWING THE FUEL PUMP FUSE.THEY THINK,BUT NOT SURE ITS THE FUEL PUMP. 2500.00 TO FIX. CORVETTE FORUM STATES THIS IS A COMMON PROBLEM. THIS IS A SAFETY ISSUE I WOULLD THINK. *TR
Jul 16, 2012
FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM
1 complaint
VEHICLE CUT OFF WHILE DRIVING @ APPROXIMATELY 25 MPH. DASH INDICATOR READ "CHECK GAUGES". I WAS ABLE TO PULL TO THE SIDE OF THE ROAD AND FOUND THAT THE FUEL PUMP FUSE HAD FAILED. TRIED ANOTHER FUSE, BUT IT BLEW IMMEDIATELY. VEHICLE WAS TOWED TO LOCAL CHEVROLET DEALER WHO HAS DIAGNOSED PROBLEM AS BOTH FUEL PUMPS HAVE SHORTS CAUSING THE FUEL PUMP FUSE TO BLOW. THIS IS A VERY DANGEROUS SITUATION AND NEEDS TO BE INVESTIGATED. IT SHOULD BE NOTED THAT AFTER A DAY OF SITTING AT THE DEALERSHIP, THE FUEL PUMP FUSE WAS REPLACED AND THE VEHICLE THEN STARTED ENABLING THE DEALER TO DIAGNOSE THE PROBLEM. CHEVROLET ZONE REP WAS CONTACTED, BUT REFUSED TO HELP. THERE IS OBVIOUSLY AN ISSUE WITH THE FUEL PUMPS AS THE REPLACEMENT FUEL PUMPS FROM CHEVROLET HAVE BEEN REDESIGNED. IT SHOULD BE NOTED THAT VEHICLE HAS ONLY 18,316 MILES. *KB
Sep 15, 2011
SERVICE BRAKES, HYDRAULIC,FUEL SYSTEM, GASOLINE
1 complaint
I OWN A 2004 CHEVROLET CORVETTE. WHILE THE VEHICLE WAS PARKED IN THE GARAGE I SMELLED A STRONG FUEL ODOR. I CHECKED AND HE REPLACED THE GASOLINE CAP, AND NOTICED A GAS PUDDLE ON THE GROUND WASHED THE VEHICLE BUT COULD STILL SMELL FUEL. THE VEHICLE WAS TAKEN TO A CHEVROLET MECHANIC WHO DIAGNOSED THE FAILURE AND CONFIRMED THAT THE FUEL TANK PIPE CONNECTORS WERE DEFECTIVE. THE FUEL TANK CONNECTORS COULD NOT BE REPLACED; THEREFORE, THE FUEL TANK HAD TO BE REPLACED. THE VEHICLE WASN'T REPAIRED. THE FAILURE MILEAGE WAS 35,400 AND THE CURRENT MILEAGE WAS 35,400. THE CHEVROLET DEALER DIAGNOSED THE FOLLOWING ISSUES: NEEDS LEFT SIDE FUEL TANK AND SENDING UNIT $3,887.50, REAR BRAKES PADS AND ROTORS $517.50, FRONT BRAKES PADS AND ROTORS $482.50, BRAKE FLUSH $165.00, INDUCTION AND INJECTOR SERVICES $350.00. SERVICE REAR POSI DIFF. $165.00. CURRENTLY I AM A CANCER PATIENT AND DUE TO MEDICAL COST I AM UNABLE TO AFFORD THE REPAIRS. THIS VEHICLE IS THE ONLY MODE OF TRANSPORTATION THAT I HAVE.ANY ASSISTANCE THAT YOU COULD AFFORD ME WOULD BE GREATLY APPRECIATED SHOULDN'T THE ISSUES BE A RECALL/SAFETY ISSUE. THANKS IN ADVANCE..R. THOMAS
Jul 21, 2011
SUSPENSION
1 complaint
TL*THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR ROUTINE MAINTENANCE WHERE THE CONTACT WAS INFORMED THE FIBERGLASS CROSSMEMBER BAR WAS CRACKING AND SEPARATING. THE VEHICLE WAS NOT REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO REFERRED HIM TO THE DEALER. THE FAILURE MILEAGE WAS 9,787. UPDATED 02/18/11 *BF THE CONSUMER STATED THE DEALERSHIP REPLACED THE PART IN QUESTION. UPDATED 03/09/11
Jan 20, 2011
ELECTRONIC STABILITY CONTROL (ESC)
1 complaint
ACTIVE HANDLING ENGAGES UNDER NORMAL DRIVING CONDITIONS ON MY 2004 CORVETTE. I LEARNED THAT THERE IS A RECALL FOR THIS FOR VEHICLES MFG FROM MARCH 2004 TO JAN 2006 WITH TELESCOPIC AND TILT STEERING WHEELS. MY CAR WAS MFG IN MAY 2004 AND HAS THE TILT /TELESCOPIC STEERING WHEEL. I WAS ALSO TOLD THAT THE RECALL WAS VIN SPECIFIC AND SINCE MY VIN NUMBER WAS NOT LISTED I HAD TO PAY FOR THE REPAIR WHICH COST ME $581AND CHANGE. I DON'T KNOW WHY MY CAR WITH THE SAME PROBLEM AND SAME DEFECTIVE PARTS WAS NOT COVERED. MY UNDERSTANDING IS THE HARNESS IS TO SHORT AND THE TELESCOPIC MOVEMENT CAUSE WEAR IN THE CONNECTOR WHICH CAUSES THE STEERING WHEEL SENSOR TO SHOW AN OPEN CONNECTION TELLING THE COMPUTER TO ACTIVATE THE HANDLING SYSTEM.. MY DEALER SAYS WAS MY PROBLEM AN OPEN SENSOR AND NOT THE CONNECTOR AND CLAIMS THEY DID NOT HAVE THE REPLACED PART TO PROVIDE TO ME...SINCE I TOTALLY LOST CONTROL OF MY CAR BUT WAS FORTUNATE NOT TO HAVE HAD AN ACCIDENT I PLAN ON REPORTING THIS COMPLAINT TO THE GMAC ,THE NEWSPAPERS IF NOT TO AN ATTORNEY TO PLEA THIS CASE FOR REIMBURSEMENT. I SUSPECT PEOPLE ARE BEING RIPPED OFF AND BEING CHARGED FOR A SENSOR REPLACEMENT INSTEAD OF OWNING UP TO THE CONNECTOR ISSUE... *TR
Sep 08, 2010
FUEL SYSTEM, GASOLINE,INTERIOR LIGHTING,ELECTRICAL SYSTEM
1 complaint
PROBLEM 1: GASOLINE SMELL WITH LEAK AND ULTIMATE FAILURE OF VALVE TO TRANSFER FUEL FROM ONE TANK TO ANOTHER. OCCURRED CONTINUALLY WITH FUEL TANK REGISTERING FULL TO 3/4 TANK THEN DROPPING TO EMPTY AND VEHICLE APPEARED TO BE OUT OF GAS (WOULD NOT RUN UNTIL FUEL ADDED TO TANK). SOLUTION: TOOK VEHICLE TO CHEVROLET DEALERSHIP FOR REPAIRS. REPAIR INVOICE STATES: "REPLACED L/S GAS TANK AND PUMP AND SENDER AND REPLACED R/S FUEL PUMP AND SENDER. CHECK FUEL GAUGE AND TANKS FOUND L/S FUEL TANK LEAKING AT TOP OF TANK. WELD ALSO FOUND FUEL LEVEL SENSORS OPEN CIRCUIT AND FUEL SYSTEM NOT TRANSFERRING FUEL FROM TANK TO TANK. RETEST AFTER REPAIRS. OK" PROBLEM 2: A/C DISPLAY LIGHTS DO NOT ILLUMINATE AND CONTROLS ARE DIFFICULT TO SEE AT NIGHT. SOLUTION: TOOK TO CHEVROLET DEALERSHIP FOR REPAIRS. REPAIR INVOICE STATES: "CONTROLLER HAS INTERNAL FAILURE, REPLACED CONTROLLER." *TR
Sep 05, 2010
FUEL SYSTEM, OTHER
1 complaint
STRONG ODOR OF FUEL INSIDE AND OUTSIDE OF MY 2004 CHEVROLET CORVETTE. BROUGHT CAR TO DEALER AND HAD TO HAVE FUEL TANK AND CROSSOVER PIPE REPLACED AT COST OF $2,200. NHTSA APPEARS TO BE LOOKING INTO RECALL OF 2004 CORVETTE FUEL TANKS. *TR
Jun 29, 2010
VISIBILITY,STRUCTURE
1 complaint
OUR CORVETTE CONVERTIBLE HAD A "RATTLE" IN THE BACK WE ID AS THE BACK WINDOW FROM THE CONVERTIBLE TOP HAD BECOME SEPARATED FROM THE ADHESIVE AND FELL OUT INTO THE BACK OF THE CAR. THIS SEEMS TO BE A PROBLEM THAT IS BEING HANDLED THROUGH THE RECALL. *TR
Dec 29, 2009
AIR BAGS,EQUIPMENT
1 complaint
#1 , I LOVE THE CHEVY 2004 CORVETTE IT IS A BEAUTY, INSIDE THE BRAIN OR COMPUTER , ITS A DANGER. ON AUG 12TH , I HAD AN ACCIDENT THAT DID NOT HAVE ANY FAILURE OF MY DRIVING ABILITIES AS PER THE FOLLOWING CODES THAT GM HAS HAD PROBLEMS WITH, AND HAVE MADE IT IMPOSSIBLE FOR A GM MECHANIC TO FIX, I DID NOT LOSE ANYTHING EXCEPT MONEY AND RESPECT FROM GM. #2 I WENT TO AN INDEPENDENT CORVETTE RACE CAR AND MECHANICAL CORVETTE SPECIALIST THAT CONFIRMED THAT THE CODES ARE MEANT TO COME AND GO, MAKING IT IMPOSSIBLE AS PER A GM CERTIFIED MECHANIC , AND SERVICE ADVISOR, I'VE TAKEN MY 2004 CORVETTE TO TWICE AND HAVE BEEN CHARGED OVER 3K USD. VARA CHEVROLET MADE MANY ERRORS, NOT CHECKING A CODE COULD END IN A FATALITY , AS PER THE ABOVE I TALKED TO ABOUT ALL THE CODES I HAVE RECEIVED ON MY CAR, AND THE TRAGEDY IS THAT GM KNOWS THIS. I RECENTLY WAS ON A TRIP TO MIDLAND, TEXAS FROM CORPUS CHRISTI, NERVOUSLY I MADE IT WITH A INSPECTION DONE CORRECTLY, NOT IN THE MANNER DESCRIBED TO THE TEXAS DOT, I PUT 4 NEW TIRES IN WHICH I HAD TO DRIVE THIS VEHICLE FROM VARA TO APPROX. 20 MILES OF FREEWAY TO GET NEW REAR TIRES AS THEY WERE BALD, FOR SOME REASON,MY CAR IS LISTED BY QUICK CHECK, A VEHICLE INFORMATION SERVICE , THAT HAS NO PHONE NUMBERS THAT MY VEHICLE WAS REPORTED IN AN ACCIDENT ON AUG 12TH AND A THEFT, WHICH HAS A CASE NUMBER, THE POLICE SAID THERE WAS NO SUCH CASE, I HAVE THE COPY THAT WAS MAILED TO ME BY ODESSA ALL AMERICAN CHEVY , I ONLY WANT MY MONEY BACK , NO CORVETTE NEEDED. I WAS TOLD I WOULD BE CHARGED WITH HARASSMENT, BY ODESSA POLICE DEPT, AND I HAVE AVOIDED ANY PHONE CONTACT. IM NOT SURE WHAT HARASSMENT IS IN THE LEGAL SYSTEM, I KNOW NOW, I AM POWERLESS. PLEASE READ THE FOLLOWING CODES DIAGNOSED AFTER MY CAR FAILED ON SAT, AND 8 TIMES ON A TRIP LAST WEEK, I HAVE BEEN OUT OF POCKET SO MUCH MONEY, AND GM HAS EVEN ADMITTED THAT THIS IS A PROBLEM, CODE IS DTC C1287 OR C1288 CIRCUIT DESCRIPTION MY EMAIL IS HACKED PLEASE CONTACT . *TR
Nov 04, 2008
STEERING,ELECTRONIC STABILITY CONTROL
1 complaint
TL*THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. WHILE DRIVING 40 MPH ON SLICK PAVEMENT, THE TRACTION CONTROL WARNING LIGHT ILLUMINATED FOR APPROXIMATELY THREE SECONDS AND THEN DIMMED AT ONE POINT, THE CONTACT DEACTIVATED THE TRACTION CONTROL IN ORDER TO CONTROL THE VEHICLE. SUDDENLY, THE VEHICLE LOST COMPLETE POWER, AND BOTH THE REAR DRIVER'S SIDE WHEEL AND STEERING WHEEL LOCKED UP. THE VEHICLE STRUCK THE MEDIAN ON THE REAR PASSENGER CORNER PANEL AND SPUN AROUND SEVERAL TIMES. THE CONTACT HAD BEEN EXPERIENCING ISSUES WITH THE VALVE STEMS LOSING PRESSURE. HE REFERENCED NHTSA CAMPAIGN ID NUMBERS 04V273000 (STEERING LINKAGES) AND 04V060000 (STEERING: COLUMN LOCKING:ANTI-THEFT DEVICE). THE CONTACT HAS PICTURES AVAILABLE. A POLICE REPORT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE 55,000. UPDATED 10/14/08 *BF UPDATED 10/23/08. *JB
Sep 16, 2008
FUEL SYSTEM, GASOLINE,FUEL SYSTEM, OTHER
1 complaint
GASOLINE LINES WERE RESIGNED IN LATE 03 INTO EARLY 04 CHEVY CORVETTES. THE RESULT WAS LEAKING GAS WHICH IS BOTH A SAFETY AND ENVIRONMENTAL HAZARD. GM DEALER REFUSED TO COVER BECAUSE DOM WAS 01/04 AND MILEAGE WAS 11982 WHEN LEAK WAS DISCOVERED. THEREFORE I HAD TO PAY INDEPENDENT AUTO REPAIR SERVICE $1945.45 THIS A MAJOR JOB. EXHAUST, TRANSMISSION, DEFECTIVE LEFT GAS TANK, ETC HAD TO BE DROPPED AND THE MOTOR TILTED TO REPLACE THE GAS LINES AND LEFT TANK. THIS A MAJOR PROBLEM AND GM FACTORY REP SAYS HE IS ONLY WILLING TO COVER $700. HELP. I HAVE ALL DOCUMENTATION INC PICS, LETTERS AND PARTS. *TR
Feb 23, 2008
PARKING BRAKE
1 complaint
PARKING BRAKE WILL NOT HOLD MY CAR ON A HILL IN NEUTRAL. MY LOCAL CHEVROLET DEALER HAD FOUR ATTEMPTS BUT IS UNABLE TO FIX THE PROBLEM. THE DEALER THEN SAID THAT THE PARKING BRAKE IS NOT INTENDED TO HOLD THE CAR BUT ONLY TO ASSIST. SAM DANIEL FROM THE NHTSA TOLD ME TO PUT IN A COMPLAINT DUE TO THE FACT THAT THE STANDARD FOR PARKING BRAKES IS TO HOLD ON A 30 DEGREE HILL FOR 5 MINUTES.*JB
Aug 17, 2005
SEATS
1 complaint
DT: ELECTRIC SEAT SHOVED CONSUMER INTO STEERING WHEEL. THE SEAT'S MOTOR CONTINUED TO PUSH THE CONSUMER FORWARD EVEN AFTER THE SEAT HAD GOTTEN TO END OF IT'S TRACK. IT WAS HARD TO UNHOOK THE FUSE IN ORDER TO STOP SEAT MOTOR. ON JULY 2, 2005 THE CONSUMER MADE AN APPOINTMENT WITH THE DEALER, WHO STATED THAT THE COMPUTER WAS THE CAUSE OF THE PROBLEM. *AK
Jul 05, 2005
Frequently Asked Questions
How many problems does the 2004 CHEVROLET Corvette have?
The 2004 CHEVROLET Corvette currently has 217 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.
What are the most common problems with 2004 CHEVROLET Corvette?
The most common problems reported for the 2004 CHEVROLET Corvette are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.
Where does this 2004 CHEVROLET Corvette problem data come from?
All problem and complaint data for the 2004 CHEVROLET Corvette comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.
Other Years - CHEVROLET Corvette
2024 Problems
2023 Problems
2022 Problems
2021 Problems
2020 Problems
2019 Problems
2018 Problems
2017 Problems
2016 Problems
2015 Problems
2014 Problems
2013 Problems
2012 Problems
2011 Problems
2010 Problems
2009 Problems
2008 Problems
2007 Problems
2006 Problems
2005 Problems
2003 Problems
2002 Problems
2001 Problems
2000 Problems
1999 Problems
1998 Problems
1997 Problems
1996 Problems
1995 Problems
1994 Problems
1993 Problems
1992 Problems
1991 Problems
1990 Problems
Other CHEVROLET Models
Similar Brands
ST
3,555 models
RS
3,484 models
NC
2,822 models
ND
2,385 models
Z
1,951 models
MOTO
1,583 models
NU
1,189 models
RC
1,122 models