How many problems does the 2006 CHEVROLET Corvette have?

The 2006 CHEVROLET Corvette currently has 413 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2006 CHEVROLET Corvette?

The most common problems reported for the 2006 CHEVROLET Corvette are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2006 CHEVROLET Corvette problem data come from?

All problem and complaint data for the 2006 CHEVROLET Corvette comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.

2006 CHEVROLET Corvette Problems

STRUCTURE

61 complaints

The contact owns a 2006 Chevrolet Corvette. The contact became aware that the VIN was included in NHTSA Campaign Number: 09V491000 (Structure). The vehicle was taken to the local dealer, where the contact was informed that the recall part was no longer available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that the part had been discontinued. The contact was advised to purchase the part from a junkyard or to order an entire roof from the dealer at his expense. The contact had not experienced a failure.

Dec 02, 2025

The contact owns a 2006 Chevrolet Corvette. The contact received recall notifications of NHTSA Campaign Number: 09V491000 (Structure) and would like to be removed from the recall distribution list because the vehicle was no longer equipped with the recalled part. The dealer and the manufacturer were contacted.

Jan 06, 2025

The contact owns a 2006 Chevrolet Corvette. The contact received notification of NHTSA Campaign Number: 09V491000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Dec 02, 2024

The contact owns a 2006 Chevrolet Corvette. The contact received notification of NHTSA Campaign Number: 09V491000(Structure); however, the part to do the repair was not yet available. No further information was provided. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Nov 05, 2024

THIS COMPLAINT IS BEING MARKED FOR DELETION BECAUSE IT IS AN INADVERTENT DUPLICATE OF ODI# 11442986*DJR The contact owns a 2006 Chevrolet Corvette. The contact stated the roof panel is delaminated. The contact stated that wind was entering the vehicle with window closed. The contact called the local dealer but vehicle was not diagnosed or repaired. The manufacturer was notified however, provided no further assistance The approximate failure mileage was 55,000. The contact stated the failure was similar to NHTSA Campaign number 09V491000 (Structure). The contact was concerned about the roof detaching,

Dec 07, 2021

+ 56 more complaints for this component

FUEL/PROPULSION SYSTEM

47 complaints

2006 Corvette convertible. Has a strong gas smell after filling up. I understand this is a common problem, but Chevrolet will not acknowledge it. The gas can drip down on the hot exhaust system, and start a fire, burning down our house, or out on the road with us in it! Please help us get this deadly problem resolved, with little expense heaped upon us. Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Oct 13, 2025

Strong fuel smell coming from the vehicle after fueling filling.

Aug 25, 2025

Vehicle is leaving a strong gas order inside and around the vehicle. This issue is currently awaiting to be inspected but for the meantime, it’s parked inside a garage where it completely fills the area with said odor. This is particularly unsafe due to our water heater also being located in this section of the house. Gas smell first appeared about a month ago and had consistently releasing these vapors. I’ve seen that GM has released a service bulletin for a short period of time but hasn’t officially recalled the fuel issue (faulty fuel system).

Jan 27, 2025

Strong smell of fuel after driven with more than 1/2 tank of fuel.

Oct 28, 2023

Fuel leaks from drivers side fuel tank. I see fuel tracks down side of tank, so conclude fuel is leaking from top of tank or from fuel pump. Fuel components are plastic, and now 17 years old, so they are probably cracked from age. I have strong smell of fuel in my garage, and puddle of fuel under drivers side tank. This is a safety hazard and must be fixed. I am aware of a number of other C6 Corvette owners with identical problems. GM must fix!

May 08, 2023

+ 42 more complaints for this component

EXTERIOR LIGHTING

45 complaints

MY HEADLIGHTS I THOUGHT WAS DONE UNDER DEALERSHIP THEN THEY STOP WORKING 2 MTHS LATER .

Apr 19, 2021

THE HEADLIGHT COVERS ARE CRAZING OVER WHICH IS MATERIALLY REDUCING THE LIGHT OUTPUT. 1. THE COVERS CANNOT BE POLISHED. NOT ONLY DOES THAT DESTROY THE OUTER COATING, THE CRAZING IS THROUGH-AND-THROUGH. 2. THE COVERS ARE GLUED ON AND CANNOT BE REPLACED BY ANY OFFICIAL MEANS, ALTHOUGH SOME INVENTIVE PEOPLE HAVE MANAGED TO SUCCEED (USUALLY AFTER MULTIPLE FAILED ATTEMPTS) BY STICKING THE ENTIRE ASSEMBLY IN THEIR KITCHEN OVEN. HOWEVER, [SEE NEXT POINT] 3. THE COVERS THEMSELVES ARE NOT AVAILABLE FOR SALE. 4. THE HEADLIGHT ASSEMBLIES THEMSELVES, WHICH COST AROUND $1,000 PER SIDE, ARE SPECIFIC TO THE COLOR OF THE CAR, AND ARE NOW DISCONTINUED. IN OTHER WORDS, THERE IS NO LEGIT PATHWAY TO FIXING THIS PROBLEM. GM MADE A THROWAWAY HEADLAMP ASSEMBLY THAT COST A FORTUNE TO REPLACE WHEN IT WAS PRODUCED, AND NOW IT'S NOT AVAILABLE AT ALL. THIS IS NOT AN OLD CAR. THESE CARS WERE PRODUCED UNTIL 2013. THREE AND A HALF YEARS LATER, YOU CAN'T GET ESSENTIAL PARTS TO MAKE THE HEADLIGHTS SAFE. THOUSANDS OF C6 HEADLAMP COVERS ARE STARTING TO FAIL NOW. THE NHTSA DID A RECALL FOR THE LOW-BEAM WIRING MALFUNCTION ON THIS CAR. THIS IS A SIMILAR PROBLEM IN ITS EFFECT.

Dec 19, 2016

I WAS ON THE INTERSTATE TRAVELING APPROXIMATELY 60MPH WHEN MY LIGHTS WENT OUT. I HAD TO PULL OVER, AND THEIR WAS A GOOD DEAL OF TRAFFIC. I DISCOVERED THAT MY BRIGHT LIGHTS WERE WORKING. I HAD THIS PROBLEM OFF AND ON FOR AWHILE. I TOOK MY CAR IN TO HAVE IT REPAIRED. I GOT IT BACK AND CONTINUED HAVING THE PROBLEM. I HAVE AVOIDED DRIVING AT NIGHT WHICH LIMITS THE USE OF YOUR CAR. MOST PEOPLE WOULD CONSIDER THIS TO BE DANGEROUS AND DEFINITELY A SAFETY ISSUE-DRIVING AND HAVING YOUR LIGHTS GO OUT IN TRAFFIC. *TR

Dec 05, 2014

TL* THE CONTACT OWNS A 2006 CHEVROLET CORVETTE. WHILE DRIVING 70 MPH, THE HEADLIGHTS FAILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 66,000.

Nov 18, 2014

TL* THE CONTACT OWNS A 2006 CHEVROLET CORVETTE. WHILE DRIVING APPROXIMATELY 35 MPH IN THE DARK, THE LOW BEAM HEADLIGHTS DIMMED. THE CONTACT HAD TO USE THE HIGH BEAM LIGHTS IN ORDER TO CONTINUE DRIVING. THE FOLLOWING DAY, THE HEADLIGHTS RESUMED NORMAL OPERATION, BUT THE FAILURE RECURRED. THE DEALER INFORMED THE CONTACT OF NHTSA CAMPAIGN NUMBER: 14V251000 (ELECTRICAL SYSTEM, EXTERIOR LIGHTING); HOWEVER, THE PART WAS UNAVAILABLE TO PERFORM THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 79,000.

Sep 29, 2014

+ 40 more complaints for this component

ELECTRONIC STABILITY CONTROL (ESC)

35 complaints

THE SERVICE ACTIVE HANDLING LIGHT APPEARED AND ALMOST LOST CONTROL OF THE CAR BECAUSE OF A RF BRAKE LOCKING UP. THE CAR WAS GOING ABOUT 40 MPH IN A CITY STREET. *TR

Jun 04, 2020

I GOT A SERVICE ACTIVE HANDLING LIGHT THAT CAME ON THE DASH TWO DAYS AGO, AND WENT AFTER RESTARTING THE CAR A FEW TIMES. WHILE I WAS DRIVE YESTERDAY AND DOING ABOUT 70 MPH, THE CAR PULLED VIOLENTLY TO THE LEFT AND I HAD TO MAKE A RAPID CORRECTION TO AVOID HITTING THE TRUCK NEXT TO ME. AS THAT HAPPENED I INSTINCTIVELY GLANCED AT MY INSTRUMENT CLUSTER AND THE SERVICE ACTIVE HANDLING, SEEMS TO HAVE LIT UP THE INSTANCE THE CAR MADE TO SUDDEN LEFT SWING. I'VE READ ON THE CORVETTE FORUMS, THAT THIS SEEMS TO BE A PROBLEM THAT HAS BEEN PLAGUING THE C6 Z06. THIS ALSO HAPPENED A COUPLE OF YEARS WHILE I WAS APPROACHING A STOP LIGHT AND WAS GOING ABOUT 25 TO 30 MPH. I DON'T USE THE CAR THAT OFTEN, ONLY WHILE I'M ON VACATION, WHICH IS ABOUT 3 TO 4 TIMES PER YEAR. THE LIGHT WILL COME ON FROM TIME TO TIME BUT THE SUDDEN LEFT SWING ONLY HAPPENED TWICE.

Jan 03, 2018

I NEVER RECEIVED ANY NOTICE FROM GM, BUT I BROUGHT IT TO THE DEALER'S ATTENTION WHILE I WAS IN FOR A RECALL REPAIR IN 2008. I TOLD THE TECH THAT MY TRACTION CONTROL, ACTIVE STABILITY CONTROL, WASN'T WORKING PROPERLY. WHEN I RECEIVED THE CAR BACK THE TECH SAID THE TRACTION CONTROL IS FIXED AND WORKING FINE. I DIDN'T SEE HOW HE COULD HAVE SAID THAT WHEN THE CAR NEVER LEFT THE SHOP. I REALIZE NOW THAT HE WAS AWARE OF SOMETHING THAT I WASN'T. THE TRACTION WASN'T FIXED, BUT I FELT THAT I CAN'T BRING IT BACK DUE TO INCOMPETENCE. I WENT TO FORUMS AND FOUND PLENTY OF COMPLAINTS FROM OTHERS. THEN I NOTICED THAT 2005-2006 CORVETTES WITH THE RPON37 STEERING COLUMN BUILT IN 2005 WERE RECALLED FOR THIS. NHTSA CAMPAIGN NUMBER WAS 10V172000 AND GM'S CAMPAIGN # WAS N100118. I CALLED GM THEY SAID I AM MISTAKEN MY CAR IS NOT AFFECTED WHICH IS [XXX]. I THEN FOUND FROM THE INTERNET THAT PART #19179794, CLIP, WAS USED TO FIX THE ISSUE. I THEN ORDERED ONE OF THESE AND FOLLOWED THE INSTRUCTIONS TO REPAIR IT AND FOUND THIS CLIP WAS INSTALLED, BUT IMPROPERLY HENCE THE REASON IT WASN'T FIXED BY THE TECH, BUT HE WAS UNDER THE IMPRESSION IT WAS SOLVED. I THEN REPLACED THE CLIP PROPERLY AND NOW IT'S OK. GM WAS VERY DIFFICULT AND DISMISSIVE DURING THE ENTIRE ORDEAL. LOOKING ON YOUR WEB SITE IT SPECIFICALLY STATES THAT MY VIN # DOES IN FACT FALL INTO THE SPECS OF YOUR RECALL. I AM GOING TO ENCLOSE A PHOTO OF THE BENT, IMPROPERLY, INSTALLED CLIP AND A PROPER PICTURE OF THE CLIP. ALSO THE HARNESS THAT NEEDS THE CLIP TO SHOW THAT THE BENT PRONG IS NEEDED TO REPAIR THE HARNESS. PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Sep 28, 2017

BRAKES LOCKED UP WHILE DRIVING DOWN BUSY ROAD. PULLED TO SIDE OF ROAD AND TURNED OF ACTIVE HANDLING SYSTEM. DROVE SHORT DISTANCE TO HOME

Jun 01, 2016

I HAVE OWNED A 2006 CORVETTE FOR ABOUT 4 YEARS NOW. THE "SERVICE ACTIVE HANDLING SYSTEM" LIGHT COMES ON IN THE DIC. IT USED TO COME ON ONCE IN A WHILE. IT NOW OCCURS EVERY TIME I DRIVE THE CAR. ABOUT 10% OF THE TIME ONE OF THE BRAKES WILL INSTANTANEOUSLY COME ON HARD THEN RELEASES IN ADDITION TO THE "SERVICE ACTIVE HANDLING SYSTEM" LIGHT COMING ON. I LIVE IN WISCONSIN SO I DON'T DRIVE IT ALL YEAR, BUT IN THE SUMMER I DRIVE IT EVERY DAY (ITS MY PRIMARY SUMMER VEHICLE). I HAVE BEEN WORKING ON CORPORATE TYPE AIRCRAFT FOR 37+ YEARS SO I AM ACCUSTOMED TO INSPECTING COMPLEX SYSTEMS. I CHECKED UNDER THE STEERING COLUMN AND FOUND AN ORANGE "WEDGE" INSTALLED INTO THE STEERING WHEEL POSITION SENSOR AND NOTICED THE ELECTRICAL LEAD GOING TO THE SENSOR APPEARS TO BE TOO SHORT WITH THE TILT / TELESCOPIC COLUMN ADJUSTED FULL AFT AND UP. I CALLED A CHEVROLET DEALERSHIP TO "FIX THE FIX" BUT THEY TOLD ME MY CAR ISN'T COVERED BY RECALL "N100118" BY VIN #. THEY INFORMED ME THAT THEY SHOW A RECORD OF A DEALERSHIP WORKING ON THIS SYSTEM BACK IN 2012? I CAN ONLY ASSUME THAT THE DEALERSHIP INSTALLED THE ORANGE WEDGE (RECALL # N100118) AT THAT TIME. I CONTACTED THE CHEVROLET OWNERS CENTER AND THEY TOLD ME THE SAME THING, NO COVERAGE DUE TO VIN #. THEY DID DOCUMENT MY COMPLAINT WITH CASE # [XXX]. AT THE END OF LAST SEASON I WAS DRIVING WITH MY WIFE IN THE CAR AT NIGHT, ON A BUSY INTERSTATE, IN A POURING RAIN. I WAS IN THE CENTER LANE WHEN THE STABILITY SYSTEM SLAMMED ON MY LEFT FRONT BRAKE. IT HAPPENED FOR JUST AN INSTANT BUT THAT WAS LONG ENOUGH TO SEND ME PARTIALLY INTO THE LANE TO LEFT OF ME. BECAUSE OF THE RAIN THE CAR LOST TRACTION AND GOT A LITTLE "SQUIRRELLY" DURING RECOVERY. IT WAS A VERY SCARY RIDE THAT COULD EASILY HAVE ENDED UP AS A MULTI-CAR CRASH. I COULD USE SOME ASSISTANCE. PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*CC

Apr 01, 2016

+ 30 more complaints for this component

ENGINE

32 complaints

while driving at ~45mph and 3500 rpm, an exhaust valve dropped on the pass side cylinder head. vehicle lost motive power. there was a hole in the block on the passenger side and the vehicle needed a long block replacement. the vehicle had 79,000 miles

Jul 11, 2023

The contact owned a 2006 Chevrolet Corvette. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. The vehicle was towed to the dealer where it was diagnosed that the exhaust valve had fractured in cylinder # 6, damaging the piston, crankshaft, and engine block. The dealer informed the contact that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 34,678.

Aug 02, 2022

2006 CHEVROLET CORVETTE, CONSUMER WRITES IN REGARD TO DEFECTIVE CRANKSHAFT PULLY. THE CONSUMER WAS SEEKING REIMBURSEMENT FOR A CRANKSHAFT SAFETY RECALL. THE MANUFACTURER WAS NOTIFIED, BUT DECLINED ANY ASSISTANCE.

Jul 15, 2022

CHEVROLET CORVETTE. CONSUMER WRITES IN REGARDS TO A DEFECTIVE CRANKSHAFT PULLY. *LD THE CONSUMER REQUESTED TO HAVE THE VEHICLE'S REPAIR COST COVERED IN FULL BY THE MANUFACTURER.*JS

Feb 26, 2021

WHEN DRIVING THE VEHICLE THE MOTOR LOCKED UP AND CAUSED A MASSIVE OIL SPILL DUE TO THE ENGINE EXPLODING.. ROOT CAUSE WAS DUE TO A DROPPED VALVE WHICH CAUSED THE WHOLE ENGINE TO BREAK INTO PIECES. THIS IS A WELL DOCUMENTED PROBLEM WITH THE LS7 MOTOR FROM GM. *TR

May 06, 2020

+ 27 more complaints for this component

STEERING

27 complaints

THIS COMPLAINT IS ABOUT SUBMITTED COMPLAINT 11350345 WHICH I NEVER RECEIVED A RESPONSE FROM NHTSA ABOUT. WHY DID I NOT RECEIVE A RESPONSE? KEVIN

Aug 28, 2020

TL* THE CONTACT OWNS A 2006 CHEVROLET CORVETTE. THE CONTACT STATED THAT WHILE DRIVING AT 35 MPH, THE VEHICLE SUDDENLY JERKED TO THE RIGHT AS THE SERVICE ACTIVE HANDLING WARNING MESSAGE ILLUMINATED. THE CONTACT WAS ABLE TO DRIVE HOME WITHOUT INCIDENT AFTER THE VEHICLE WAS INSPECTED. UPON INVESTIGATION, THE CONTACT DISCOVERED NHTSA CAMPAIGN NUMBER: 10V172000 (STEERING) WHICH THE CONTACT LINKED WITH THE FAILURE. THE CONTACT SPOKE TO BOTH THE MANUFACTURER AND PELTIER CHEVROLET (2700 W. SW LOOP 323, TYLER, TX 75701) WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000.

Apr 13, 2020

THE POWER STEERING HIGH PRESSURE LINE LEAKS IN MULTIPLE PLACES THROUGH A SHORT CANVAS REINFORCED RUBBER SEGMENT ON MY 2006 CORVETTE, NOT THROUGH ANY CRIMPED FITTINGS, O-RINGS, ETC. THE HIGHER THE RPM, THE FASTER IT LEAKS. IT SPRAYS ON THE ENGINE AND EXHAUST. THE SOURCE OF THE LEAK WAS DIFFICULT TO FIND SHORTLY AFTER PURCHASE (USED), BEING THE HOSE ITSELF IS HARD TO SEE, THE LEAK WAS SMALLER THEN, AND IT HAD A CORRUGATED PLASTIC TUBING WRAPPED AROUND IT FOR ABRASION PROTECTION, DIVERTING THE LEAKS. NOW IT'S LEAKING BADLY. THE HOSE IS BENT IN A CURVE, AND THE LEAKS ARE ALL ALONG THE OUTER PERIMETER (STRETCHED) SIDE OF THE HOSE. I DISCOVERED THE REPLACEMENT STEEL LINE HAS BEEN REDESIGNED TO A LONGER UNIT WITH TWO STRAIGHT RUBBER SECTIONS THAT MUST BE REROUTED, WHICH TOLD ME THE ORIGINAL HAD A DESIGN FLAW THAT LED TO FAILURES. I CHECKED TO SEE IF THERE WAS A RECALL FOR THIS, AND THERE IS, BUT ODDLY MY VIN SEEMS TO 'NOT BE INCLUDED'. RECALL #05V455000 IS DATED 10/5/2005, AND THE DATE MY CAR WAS BUILT IS 09/05 ACCORDING TO THE DOOR DECAL. THE RECALL STATES: 'CONSEQUENCE: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.' THE DEALERSHIP INSISTS MY VIN IS NOT EFFECTED, BUT YET I CLEARLY HAVE THIS PROBLEM NOW ON A HOSE THAT IS NOTHING LIKE THE NEWLY-DESIGNED ONES. I THINK GM MUST INCLUDE MY VIN AND ALL ADDITIONAL ONES WITH THIS OLD STYLE HOSE INSTALLED, I THINK IT 'SLIPPED THROUGH THE CRACKS'. IT'S SPRAYING FLUID ON HOT EXHAUST BENEATH, AND IT LOSES LOTS OF FLUID QUICKLY WHICH CAN LEAD TO STEERING/BRAKE FAILURE. I CAN'T DRIVE THE CAR IN THE STATE IT'S IN.

Aug 17, 2019

STEERING WHEEL LOCKED WHILE DRIVING

Jul 23, 2019

Crash: 1

TL* THE CONTACT OWNS A 2006 CHEVROLET CORVETTE. WHILE DRIVING 35 MPH, THE ACTIVE HANDLING SYSTEM ENGAGED AND THE FRONT END OF THE VEHICLE SHOOK. THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE. THE DEALER WAS NOTIFIED AND STATED THAT THERE WAS NO RECALL FOR THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 65,000.

Feb 06, 2018

+ 22 more complaints for this component

POWER TRAIN

26 complaints

WHEN I START MY CORVETTE AND ATTEMPT TO SHIFT MY AUTOMATIC TRANSMISSION FROM PARK TO DRIVE, THE SHIFTER WILL NOT MOVE OUT OF THE PARK POSITION.

Sep 13, 2020

THE SHIFTER IS CONNECTED TO THE TRANSMISSION WITH A 4 FOOT CABLE, THIS CABLE IS HOUSED IN THE DRIVE SHAFT TUNNEL, THE CABLE HAS A PLASTIC BUSHING ON BOTH ENDS, THE HEAT IN THE TUNNEL BAKES THE PLASTIC BUSHING THAT CONNECTS THE SHIFTER TO THE TRANSMISSION CABLE, MY BUSHING BROKE INTO PIECES AND THE CAR COULD NOT SHIFT INTO OR OUT OF GEAR. MANY CORVETTES IN THE C5,C6 & C7 MODES HAVE THIS SAME ISSUE AND ARE FAILING EVERYDAY. MY CAR WAS IN THE GARAGE IN PARK, I HAD DRIVEN IT EARLIER IN THE DAY, I STARED THE CAR AND THE SHIFTER WOULD MOVE, BUT THE PLASTIC BUSHING HAD BROKEN INTO PIECES DUE TO THE HEAT FAILURE. I KNOW OF THE HAPPENING TO 4 OTHER CORVETTES AND THE SHOP I TOOK MY CAR TO WAS RECEIVING OTHER CALLS ON THE SAME ISSUE.

Jul 24, 2019

CAR WILL REFUSE TO SHIFT OUT OF PARK DURING NORMAL START. CAR WILL REFUSE TO SHIFT OUT OF PARK WHEN IN ACC MODE. PROBLEM IS NON DETERMINISTIC AND MAY BE RELATED TO VOLTAGES AND/OR RESISTANCES AND/OR FAULTY PARTS IN SYSTEM. CAR IS RENDERED NON-OPERABLE AND REQUIRES TOWING OR REPEATED ATTEMPTS TO RELEASE GEAR TRAIN OVER A VARIABLE PERIOD OF TIME. THIS SEEMS TO BE A WELL KNOWN MANUFACTURING DEFECT NOT ADDRESSED BY THE MANUFACTURER

Jun 27, 2019

AUTOMATIC TRANSMISSION SHIFT LOCK SOLENOID FAILS, PREVENTING TRANS. TO LOCK INTO PARK AND OR CAN'T PLACE TRANSMISSION IN PARK. GM CORRECTED THIS CONDITION STARTING WITH VIN NUMBER 75405780, VIN NUMBERS BEFORE THAT STILL CONTINUE TO HAVE THIS SAFETY CONDITION

May 06, 2019

SHIFTER STIFF AND IS VERY HARD TO SHIFT INTO GEAR ON AUTOMATIC TRANSMISSION

Apr 29, 2019

+ 21 more complaints for this component

ELECTRICAL SYSTEM,EXTERIOR LIGHTING

17 complaints

TL* THE CONTACT OWNS A 2006 CHEVROLET CORVETTE. WHILE ATTEMPTING TO DRIVE THE VEHICLE AT NIGHT, THE CONTACT BECAME AWARE THAT THE HEADLIGHTS FAILED TO ILLUMINATE. THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 14V251000 (ELECTRICAL SYSTEM, EXTERIOR LIGHTING), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE EVENING OF THE RECALL REPAIR, THE HEADLIGHTS FAILED TO ILLUMINATE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 133,900.

Sep 28, 2015

TL* THE CONTACT OWNS A 2006 CHEVROLET CORVETTE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V251000 (ELECTRICAL SYSTEM, EXTERIOR LIGHTING) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE VIN WAS NOT AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

Dec 02, 2014

TL* THE CONTACT OWNS A 2006 CHEVROLET CORVETTE. THE CONTACT STATED THAT WHEN THE VEHICLE REACHED NORMAL OPERATING TEMPERATURES, THE LOW BEAM LIGHTS BECAME INOPERABLE. THE VEHICLE WAS TAKEN TO THE DEALER. HOWEVER, THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT RECEIVED A NOTIFICATION FOR RECALL NHTSA CAMPAIGN NUMBER: 14V251000 (ELECTRICAL SYSTEM, EXTERIOR LIGHTING) BUT THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 119,000.

Nov 07, 2014

MY LOW BEAM LIGHTS STOPPED WORKING. GOT HAD DRIVEN TO A LOCATION IN DAYLIGHT. 2 HOURS LATER (DARK) I STARTED THE CAR AND THE LOW-BEAMS DIDN'T COME ON. I GOT HOME (ON FOG LAMPS) AND INSPECTS THE FUSE BOX. THOUGHT THE LOW BEAM RELAY WAS FAULTY SO WENT IN ANOTHER VEHICLE TO PURCHASE ONE. REPLACING THE RELAY, THE LIGHTS CAME BACK ON. I THOUGHT THE PROBLEM WAS FIXED UNTIL THE NEXT DAY, THE SAME THING HAPPENED. THIS IS WHEN I DID SOME RESEARCH AND FOUND MY CAR IS PART OF A GM RECALL; GM RECALL #: N130146 NHTSA RECALL #: 14V-251 DATE ISSUED: MAY 28, 2014 THIS SAME SYMPTOM HAS HAPPENED EVERY DAY SINCE. I BOOKED MY CAR INTO LONESTAR CHEVROLET, HOUSTON, TO HAVE THIS TAKEN CARE OF. THE TECHNICIAN, MANAGER AND CHEVROLET CONTACT CENTER ALL TOLD ME THE SAME THING. "THE PARTS TO REPAIR THIS AREN'T READY YET (4 MONTHS!!). YOU ARE PERFECTLY SAFE TO DRIVE ON HIGH-BEAMS." IN MY OPINION, IT IS IRRESPONSIBLE TO TELL YOUR CUSTOMER THAT THERE IS NOTHING THAT CAN BE DONE AND TO DRIVE ILLEGALLY AT NIGHT IN THE MEAN-TIME. *TR

Sep 17, 2014

TL* THE CONTACT OWNS A 2006 CHEVROLET CORVETTE Z06. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V251000 (ELECTRICAL SYSTEM, EXTERIOR LIGHTING). THE DEALER COULD NOT REPAIR THE VEHICLE FOR TWO MONTHS BECAUSE THE PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

Sep 12, 2014

+ 12 more complaints for this component

ELECTRICAL SYSTEM

16 complaints

I HAVE A 2006 CHEVROLET CORVETTE AND IT HAS A PART THAT IS IN THE PROCESS OF FAILING. THE DASH CONTROL UNIT (PART # 25938052) IS FLASHING, WHICH MY CHEVROLET DEALER TELLS ME IT IS GOING TO FAIL. THIS IS AN IMPORTANT SAFETY ISSUE, AS I COULD LOOSE MY DEFROSTER CAPABILITY, FRONT AND BACK WHILE DRIVING. I HAVE VISITED 5 DIFFERENT GM DEALERS AND THEY ALL SAY THE PART IS EITHER BACK ORDERED OR DISCONTINUED. I CAN'T GET A STRAIGHT ANSWER. SINCE THIS PART WAS INSTALLED IN CORVETTES UP TO 2012 MODEL YEAR, I FIND CHEVROLETS INDIFFERENCE TO THIS SAFETY ISSUE DISTURBING. I HAVE ATTEMPTED TO CONTACT CHEVROLET ONLINE SEVERAL TIMES AND THEY RECENTLY CUT ME OFF AND HAVE FAILED TO RESPOND TO E-MAILS. I HAVE HEARD ANECDOTALLY, THAT CHEVROLET HAS MANY PARTS "BACK-ORDERED" WINK, WINK. THEY KEEP TRYING TO SELL ME A NEW CAR, BUT WHY WOULD I BUY ANOTHER CAR FROM THEM WITH THIS BEHAVIOR? THE PART STILL WORKS FOR NOW, BUT IT BLINKS CONSTANTLY AND I NEVER KNOW WHEN IT IS GOING TO FAIL. ISN'T GM REQUIRED BY LAW TO SELL REPLACEMENT PARTS FOR A REASONABLE TIME?

Oct 02, 2018

MY AUTOMATIC SHIFTER GETS STUCK IN PARK. I ALREADY HAD THE DEALERSHIP REPLACE THE SHIFTER A FEW YEARS AGO BUT THE PROBLEM STILL REMAINS. ONCE I START THE CAR, THE SYSTEM DOES NOT TELL THE SHIFTER TO UNLOCK AND THEREFORE I CAN NOT GET IT IN GEAR. I HAVE TO PLAY WITH IT SEVERAL TIME. IT MAY TAKE LESS THAN 1 MINUTE TO ENGAGE WHILE AT OTHER TIMES IT MAY TAKE 5 MINUTES. I HAVE READ IN THE CORVETTE FORUM THAT IT IS HAPPENING TO QUITE A FEW CORVETTE OWNERS. THIS IS HAPPENING MUCH MORE FREQUENTLY THAN BEFORE.

Aug 19, 2018

4/2015 CAR WAS AT DEALERSHIP FOR BODY WORK, WHILE IT WAS THERE, RECALL WORK WAS SUPPOSED TO BE DONE, GM RECALL 123146, I WAS TOLD THAT THIS WAS DONE AND IT WAS REPORTED TO GM AS "WORK DONE" FAST FORWARD TO 8/2018 CAR WAS DRIVEN AT NIGHT AND LOSS OF LOW BEAM HEADLIGHTS WAS EXPERIENCED, SAME THING HAPPENED NEXT DAY. THESE ARE THE SYMPTOMS OF THE RECALL BEFORE "THE FIX" UPON FURTHER INVESTIGATION IT WAS FOUND THAT THE RECALL WAS NOT DONE. I HAVE PICTURES OF THE FUSE BOX AND I HAVE PICTURES OF WHAT ITS SUPPOSED TO LOOK LIKE WHEN THE FIX IS DONE.

Aug 13, 2018

WHILE DRIVING, THE CHECK CHARGING SYSTEM LIGHT COME ON, VOLTAGE ON THE GAGE WENT TO 11.5 VOLT. I CHANGE THE ALTERNATOR, AFTER INSTALLING THE NEW REBUILD ON THE GAGE WHEN UP TO 14.5. I TOOK IT FOR A TEST DRIVE. THAT ONLY LASTED 20 MINUTES. WITHIN 2 SATURDAY, I HAVE ADDED 6 ALTERNATOR TO THIS CAR, THEY ONLY LAST 20 MINUTE AFTER IN STALLING. HAD THE CAR CHECK OUT. I WAS TOLD THAT IT WAS A BAD ALTERNATOR. I HAVE NEVER CHANGED SO MANY ALTERNATOR IN MY LIFE ON ONE CAR. TAKING IT INTO A SHOP THIS WEEKEND AGAIN AND LET THEM INSTALL THERE $800.00 ALTERNATOR AND SEE WHAT HAPPEN.

May 19, 2017

TL* THE CONTACT OWNS A 2006 CHEVROLET CORVETTE. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V251000 (ELECTRICAL SYSTEM, EXTERIOR LIGHTING). HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VIN WAS UNAVAILABLE.

Dec 03, 2014

+ 11 more complaints for this component

AIR BAGS

15 complaints

Air bag light goes on and mostly when driver seat is adjusted

Sep 21, 2023

Air bag warning light comes on intermittently...goes away when I move the seat back and forth indicating there is faulty wiring with this vehicle. Apparently according to a corvette forum, this is a common problem, which tells me there is a chance that the problem possibly came from the factory.

Jul 10, 2023

Air bag light is on. Common problem with corvettes that GM will not recall

May 22, 2021

AIR BAG LIGHT COMES ON FREQUENTLY DURING NORMAL DRIVING. CAR HAS NEVER BEEN IN AN ACCIDENT AND IS IN EXCELLENT CONDITION OTHERWISE. AIR BAG LIGHT WILL TURN OFF INTERMITTENTLY DURING NORMAL DRIVING WITH NO EXPLANATION.

Feb 13, 2019

DRIVERS AIRBAG RED LIGHT ON INSTRUMENT PANEL STAYS ON FREQUENTLY. MOST OF THE TIME IT STAYS LIT AFTER STARTING THE CAR. I HAVE HAD IT POP ON AFTER HITTING A BUMP A COUPLE TIMES.

May 15, 2018

+ 10 more complaints for this component

SERVICE BRAKES

8 complaints

I have a potential AH/TC (Active Handling) system problem. Today the “Service Active Handling System” light came on and upon search of the fix within my Corvette community I discovered that it is potentially a DEADLY issue where brakes may lock up on the freeway! PLEASE send me information on a fix with GM or where this is at in the process in regards to a recall. Thank you for your attention to this apparently deadly issue.

Aug 16, 2021

TL* THE CONTACT OWNS A 2006 CHEVROLET CORVETTE. WHILE DRIVING AT VARIOUS SPEEDS DOWN A HILL THE BRAKES AND SERVICE ACTIVE HANDLING SYSTEM SPONTANEOUSLY ENGAGED. IN ADDITION, WHILE IN REVERSE THE BRAKES ACTIVATED INDEPENDENTLY WITHOUT WARNING. THE TPMS WARNING LIGHT WAS ILLUMINATED. THE LOCAL DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 78,000. *DT*JB

Feb 07, 2020

HELLO MY NAME IS [XXX] I AM 64 YEARS OLD. ON SUNDAY 9/18/2016 WHILE DRIVING MY 2006 CORVETTE WITH MY WIFE IN THE PASSENGER SEAT WE NEARLY HAD AN ACCIDENT. I WAS GOING AROUND 70 WHEN THE CAR ALL OF A SUDDEN BRAKE AND PULLED TO THE LEFT. WE WERE BOTH SHOOK UP BY THIS. WE RIGHT AWAY PRESSED OUR ON-STAR BUTTON. WE HAD THEM RUN A DIAGNOSTIC TEST. ON-STAR WAS UNABLE TO GET A READING ON THE CAR. WE TOLD ON-STAR THAT THE DASH BOARD DISPLAYED THE FOLLOWING MESSAGE "SERVICE ACTIVE HANDLING SYSTEM". AS SOON AS WE GOT HOME MY WIFE LOOKED UP THIS ISSUES AND NOTICED THERE WAS A RECALL FOR THIS PROBLEM IN 2010 #[XXX]. MY CAR IS A 2006 CORVETTE VIN# [XXX]. I CALLED THE DEALERSHIP THAT MONDAY 9/19. THE DEALERSHIP IS ANCIRA WINTON 6111 BANDERA RD SAT 78238. I WAS INFORMED THAT THE PREVIOUS OWNER HAD BROUGHT THE CAR INTO THE DEALERSHIP TO HAVE THIS RECALL FIXED. SO BASICALLY I WAS OUT OF LUCKY BECAUSE IT HAD BEEN FIXED. WELL I SAY NO IT HAS NOT BEEN FIXED I HAVE A PICTURE OF WHAT APPEARED ON MY DASH BOARD WHICH I HAVE ATTACHED. MY WIFE THEN CALLED THE NHTSA TO FILE A COMPLIANT AS TO THE FACT THE DEALERSHIP WILL NOT REPAIR THIS .I HAVE ONLY 22,700 MILE ON THIS CAR. I HAVE NOT DRIVEN IT SINCE THIS INCIDENT WHICH CAN BE CONFIRMED BY ON-STAR. MY WIFE WAS GIVEN A COMPLIANT CASE # 10908378. SHE WAS INFORMED TO SIGN ONTO WWW.SAFETYCAR.GOV. AS OF TODAY WE CAN NOT LOCATE THIS COMPLAINT. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Sep 26, 2016

TL* THE CONTACT OWNS A 2006 CHEVROLET CORVETTE. WHILE DRIVING AT APPROXIMATELY 60 MPH, THE PASSENGER SIDE BRAKE CALIPER ENGAGED AND THE CONTACT LOST CONTROL OF THE VEHICLE. THE CONTACT MENTIONED THAT UNKNOWN WARNING INDICATORS ILLUMINATED IMMEDIATELY AFTER THE FAILURE OCCURRED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

Jul 09, 2015

BRAKES CAME ON CAR SWERVED. *TR

Apr 19, 2015

+ 3 more complaints for this component

STEERING,ELECTRONIC STABILITY CONTROL (ESC)

7 complaints

WHEN I MOVE THE STERRING WHEEL COMPLETELY TO THE LEFT THE CAR HAVE AND INTERRUPTION AND PULL TO THE LEFT OR RIGHT AND THE SERVICE ACTIVE HANDLING SYSTEM MESSAGE APPEARS

Oct 17, 2019

BEGAN TO NOTICE A SENSED VEHICLE SELF STEERING SENSATION ON 7/12/17. THE VEHICLE FEELS LIKE THE REAR WHEELS ARE SLIDING AROUND WITH NO TRACTION OR AS IF THE REAR WHEELS ARE STEERING THEMSELVES. IT IS OCCURRING AT ALL SPEEDS, EVEN WHILE DRIVING UP AN INCLINED DRIVEWAY.

Jul 13, 2017

IN 2010, THERE WAS A RECALL ON MY VEHICLE FOR "STEERING WHEEL POSITION SENSOR." THE ISSUE WAS THE "SERVICE ACTIVE HANDLING" WARNING NOTICE WAS INTERMITTENTLY APPEARING IN THE DRIVER INFORMATION CENTER. THE REMEDY WAS TO INSTALL A PLASTIC CLIP. THIS REMEDY DID NOT FIX THE ISSUE AND I WAS TOLD I NEEDED A NEW "STEERING WHEEL POSITION SENSOR" AND THAT IT WAS NOT COVERED BY THE RECALL AND IT WOULD BE AT MY EXPENSE. I DID NOT HAVE THE REPAIR DONE AT THAT TIME BECAUSE I RARELY DRIVE THE CAR, AND THE PROBLEM WAS INTERMITTENT. THE DEALERSHIP ADVISED ME TO HAVE A FRONT END ALIGNMENT AND THAT SEEMED TO FIX THE PROBLEM FOR AWHILE. THE "SERVICE ACTIVE HANDLING" WARNING HAS RETURNED, AND I'M SCHEDULED TO HAVE THE SENSOR REPLACED FOR ABOUT $800. THIS SEEMS TO BE A WIDELY KNOWN PROBLEM IN THE 2005-2006 CORVETTES, AND THE PLASTIC CLIP DID NOT FIX THE ISSUE. I'M EXTREMELY CONCERNED AS THERE HAVE BEEN MANY BAD ACCIDENTS DUE TO THE ACTIVE HANDLING SYSTEM ENGAGING AT RANDOM TIMES AND CAUSING CRASHES. WHY DIDN'T GM ACKNOWLEDGE THAT THE PLASTIC CLIP DID NOT REMEDY THE ISSUE AND WHY AM I HAVING TO PAY FOR A REPAIR THAT IS WIDE SPREAD AND THAT THE RECALL REPAIR IS KNOWN TO NOT HAVE WORKED. *TR

Dec 27, 2016

TL* THE CONTACT OWNS A 2006 CHEVROLET CORVETTE. WHILE REVERSING THE VEHICLE AT APPROXIMATELY 5 MPH, THE SERVICE RIDE CONTROL WARNING INDICATOR ILLUMINATED. THE CONTACT ALSO OBSERVED THAT THE STEERING WHEEL PULLED IN THE OPPOSITE DIRECTION OCCASIONALLY. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V172000 (STEERING). THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000.

Aug 22, 2016

RARELY, DURING LOW SPEEDS (UNDER 15 MPH), WHILE DRIVING STRAIGHT, THE LEFT REAR WHEEL WILL LOCK UP, INDUCING A HARSH LEFT TURN, UNSTABLE MANEUVERING, AND CAUSING THE MOTOR TO ATTEMPT TO STALL. STEERING IS EXTREMELY UNSTABLE AND VIOLENT AND OPERATOR HAS TO FIGHT AGAINST THE CAR WANTING TO TURN LEFT BY APPLYING EXTREME RIGHT TO THE STEERING WHEEL. THE ONLY REMEDY IS TO ENGAGE AND DISENGAGE THE CLUTCH SEVERAL TIMES UNTIL THE LEFT REAR WHEEL UNLOCKS. SYMPTOMS HAVE NOT OCCURRED DURING NORMAL TRAFFIC SPEEDS (ABOVE 15 MPH). AUTO HANDLING/TRACTION CONTROL AND ABS LIGHTS ARE ACTIVATED DURING THIS EVENT. VEHICLE IS IN FACTORY CONDITION. ONLY EXCEPTION IS ALTERNATE BRAND OF TIRE (NITTO INVOS) - BUT MAINTAINING FACTORY SPECIFICATIONS (FRONT: 275/35ZR18; REAR: 325/30ZR19). HAVE NOT REPORTED TO MANUFACTURER YET (IT IS TOO RANDOM AND RARE TO REPRODUCE ON A PREDICTABLE OCCURRENCE). ENVIRONMENTAL CONDITIONS: NORMAL (SUNNY, DRY PAVED SURFACE).

Oct 10, 2015

+ 2 more complaints for this component

STEERING,SERVICE BRAKES

6 complaints

I purchased this car from a dealer in Sarasota Florida. Driving it home from the dealer, I was driving approximately 70 mph on [XXX] near Sarasota. The vehicle suddenly braked and pulled to the left simultaneously. I have taken it to a repair shop that specializes in Corvettes, and trying to ID the problem. In doing research, evidently it is related to the active handling system. There is a recall NHTSA Campaign Number: 10V172000 Manufacturer GENERAL MOTORS CORP. Components STEERING Potential Number of Units Affected 40,028 and a service bulletin 10118. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Jan 29, 2025

my service active handling and traction control light will come on randomly and disappear, when it does come on usually my car will brake on one side of the car and skip and skid over to one side. when it happens I have zero control of the braking and steering and it has taken my car into another lane completely. it is terrifying and I've had the whole brake system replaced, along with ecm, ebcm, rack and pinion all suspension and steering components, wiring harness and just about everything I could think of that may cause it. I have a tilting telescope steering wheel and I've heard that they can cause this

Nov 05, 2022

On numerous occasions the past two years the active handling system in the vehicle will take control for no reason and brake on one side causing the car to swerve out of its lane and other times applies the brakes on its own. Very dangerous.

Jul 20, 2021

TL* THE CONTACT OWNS A 2006 CHEVROLET CORVETTE. WHILE DRIVING 30 MPH, THE ACTIVE HANDLING SYSTEM ENGAGED AND THE FRONT END OF THE VEHICLE BEGAN TO SHAKE. WHILE THE ACCELERATOR PEDAL WAS DEPRESSED, THE BRAKES ENGAGED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO MICHAELS TOYOTA OF FRESNO, CALIFORNIA (50 WEST BULLARDS AVE, (559) 431-7576 93704), BUT THE SOURCE OF THE FAILURE COULD NOT BE DETERMINED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT INDICATED THAT NHTSA CAMPAIGN NUMBER: 10V172000 (STEERING) WAS A POSSIBLE EXPLANATION FOR THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000.

Oct 12, 2017

TL* THE CONTACT OWNS A 2006 CHEVROLET CORVETTE. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE BRAKED INDEPENDENTLY AND "SERVICE ACTIVE HANDLING SYSTEM ERROR" ILLUMINATED ON THE MESSAGE BOARD. THE CONTACT HAD TO RESTART THE VEHICLE IN ORDER FOR IT TO OPERATE PROPERLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT WAS AWARE THAT THE PREVIOUS OWNER REPAIRED THE VEHICLE PER NHTSA CAMPAIGN NUMBER: 10V172000(STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 22,000.

Sep 21, 2016

+ 1 more complaint for this component

UNKNOWN OR OTHER

6 complaints

This is a safety concern when I start my car and can not put it in reverse. This in todays world of violence and crime everywhere is truly a safety concern for women stuck in a car that you can not get out of park. The shift is stuck in park and will not move in any other position. Looking on the web this is a known problem on many 2005 and 2006 Corvette's for years. This has happened to many times to count.

Apr 06, 2023

Shifter assembly does not operate properly. The shifter locks and will not move from park to reverse or neutral or drive. Therefore, the car is inoperable. Many suggestions are to override such lockout mechanism however this creates a major safety issue. The car was at dealership, and they could not resolve problem, nor could they locate a replacement shifter assembly. I believe GM’s lack of providing parts, TSB or other remediations for this well-known issue will result in owners creating an unsafe vehicle and overriding the safety lockout that is not working. Therefore, I strongly would like NHTSA to launch an investigation.

Aug 04, 2021

AS OF DECEMBER 2018, ALL CARS WITH NAVIGATION SYSTEMS THAT HAVE AN INCORPORATED CLOCK, CLOCKS STOPPED WORKING, THE REASON IS SUPPOSABLY DUE TO A CHANGE IN THE GOVERNMENT SATELLITE TECHNOLOGY. SO THERE IS NO WAY TO CORRECT THIS WITHOUT A SOFTWARE FIX, THIS PROBLEM IS NOT ONLY ON THE 2006 CORVETTE, BUT MANY OTHER CARS AS WELL

Jun 19, 2019

2006 CHEVROLET CORVETTE. CONSUMER STATES THAT WHILE DRIVING 30 MPH THE ACTIVE HANDLING SYSTEM ENGAGED AND THE FRONT END OF VEHICLE BEGAN TO SHAKE. *LD THE CONSUMER STATED THE DEALER COULD NOT DUPLICATE THE FAILURE. *JS

Feb 09, 2018

AFTER CAR PURCHASE , ON MULTIPLE OCCASIONS WHILE TURNING RIGHT AT VERY SLOW SPEEDS THE STEERING WHEEL WOULD ALMOST LOCK-UP AND THE BRAKES WOULD APPLY AND KIND OF PUMP THEMSELVES AND THE THE SERVICE "TRACTION CONTROL SYSTEM " LIGHT WOULD COME ON .ONCE DURING A RT. TURN ON A GREEN ARROW IT HAPPENED AND THE CAR BEHIND ME ALMOST HIT ME BECAUSE THE CAR ALMOST STOPPED DURING THE TURN .I HAD THE SAME PROBLEM WITH AN 05 CORVETTE ONLY NOT AS BAD . THE PROBLEM HAS HAPPENED 5 OR 6 TIMES SINCE I BOUGHT THE CAR , IN VARYING DEGREES . I BOUGHT THE CAR USED AS IS OR I WOULD HAVE RETURNED IT TO THE DEALER SINCE I'M SURE THEY KNEW ABOUT THE PROBLEM . I TOOK IT AND HAD THE CAR FIXED. IT COST ME $371. THE REPAIR SHOP FOUND THEABS & TRACTION CONTROL SENSOR AND STEERING ANGLE SENSOR NOT WORKING RIGHT AND REPLACED THEM. ONLY 30000 MILES !!

Sep 18, 2015

+ 1 more complaint for this component

POWER TRAIN,ENGINE

4 complaints

WHEN DRIVING THE VEHICLE, I CAN HEAR, AS IT SEEMS TO ME, EXCESSIVE VALVE TRAIN NOISE.

Apr 30, 2020

I WAS DRIVING IN S 35 MPH ZONE AND IT CHANGED TO 45 MPH. I WAS IN 2 OR 3RD GEAR AND HAS JUST STARTED UP A SLIGHT INCLINE AND I WAS INCREASING SPEED WHEN THE CAR MADE A SUDDEN JERK AND LOUD ALMOST A BANG. I DEPRESSED THE CLUTCH AND IT STAYED ON THE FLOOR. I THOUGH THAT THE CLUTCH HAD CAME APART AND I PULLED THE PEDAL UP TO SEE WHAT WAS GOING ON. THE ENGINE AT THAT POINT WAS RUNNING VERY ROUGH AND WOULD NOT HOLD SPEED OR ACCELERATE. I PULLED INTO A PARKING LOT AND GOT MY WIFE TO PICK ME UP. I THEN GOT MY PICKUP AND TRAILER AND TOOK THE CAR TO CLASSIC CHEVROLET. THEY FOUND WHERE THE VALVE HAD DROPPED INTO THE CYLINDER AND CAUSED DAMAGE TO THE PISTON AND ROD. I LOOKED AT THE ENGINE WHILE TORE DOWN AND NOTICED WHAT APPEARED TO ME TO BE A CRACK IN THE CYLINDER WALL AND POINTED IT OUT, THE FORMAN SAID THE HAD CHECKED IT AND DIDN'T FEEL THAT IT WAS A CRACK. THEY ADVISED ME TO GET A NEW HEAD AND HAVE THE OTHER HEAD WORKED ON AS WELL AS A PISTON, ETC. I DID THAT AND HAD THE CAR REPAIRED. WHEN THE CAR JERKED IT ALSO AFFECTED THE PRESSURE PLATE SO I HAD THAT REPLACED. AFTER I GOT THE CAR BACK I NOTICED IT WAS SMOKING WHITE VAPOR WHENEVER I STARTED IT. I TOOK IT BACK TO THE DEALERSHIP AND THE TESTED IT AND SURE ENOUGH IT WAS A CRACK IN THE CYLINDER. I THEN HAD THE MOTOR REPLACED AND THE DEALERSHIP WAS VERY FAIR AND CREDITED THE EARLIER WORK AGAINST THE MOTOR. WHEN THE MOTOR LET LOOSE, THE CAR LOCKED THE BACK WHEELS AND THE CAR BEHIND ME HAD TO MAKE A RATHER QUICK STOP AND DODGE ME SO AS NOT TO HAVE A WRECK.

Apr 06, 2020

I BOUGHT THIS CORVETTE Z06 USED FROM A PRIVATE PARTY. THE ENGINE HAD A CATASTROPHIC FAILURE DUE TO A KNOWN ISSUE WITH THE VALVE GUIDES AND VALVES IN THE LS7 MOTOR FROM THE FACTORY. I WAS DRIVING HOME FROM WORK WHEN THE MOTOR FAILED. I WAS LUCKY TO BE ONLY A MILE FROM HOME WHEN IT FAILED AND I WAS ABLE TO COAST INTO MY GARAGE. THE EXHAUST VALVE DROPPED AND DESTROYED THE #1 PISTON ALONG WITH THAT CYLINDER, AND THE ENGINE BLOCK. NOTHING IN THE MOTOR IS SALVAGEABLE AS IT BENT OR SENT METAL SHARDS INTO EVERY PART OF THE MOTOR. I HAVE TRIED SEVERAL TIMES TO GET CHEVY TO HELP ME WITH THIS MOTOR, BUT THEY WILL NOT HELP AT ALL. THEY KNOW ABOUT THE PROBLEM, BUT WILL NOT LIFT A FINGER TO HELP ANYONE. *TR

Apr 15, 2015

MASSIVE ENGINE FAILURE DUE TO A FAILED EXHAUST VALVE AFTER INSPECTION, CAR LOST ALL POWER AND WAS IMMOBILE AFTER ROLLING TO A STOP. THE 7 AND 8 CYLINDER ON THE BLOCK WERE COMPLETELY VENTILATED. THIS IS A VERY COMMON PROBLEM WITH 2006-2011 CORVETTES AND MANY OTHERS HAVE HAD THE SAME ISSUE.WHAT HAPPENS IS THE HEAD OF THE EXHAUST VALVE FALLS OFF AND THEN IT MAKES CONTACT WITH THE PISTON AND TAKES OUT THE BLOCK AND PISTON AND RODS. PLEASE INVESTIGATE THIS AS THERE IS SEVERAL HUNDRED OR MORE Z06 EQUIPPED WITH THE LS7 MOTOR THAT HAS HAD THE SAME ISSUE. IT IS A SAFETY CONCERN AND IMHO THERE SHOULD BE SOME KIND OF RECALL ON THESE MOTORS. *TR

Oct 09, 2012

Fire: 1

ENGINE AND ENGINE COOLING

3 complaints

I HAVE 2006 CHEVY CORVETTE WHAT A JOKE THIS CAR HAS BEEN. I HAVE HAD A NEW ENGINE I HAVE SPENT 40,000 ON REPAIRS TO THIS CAR ITS NEVER ENDING.I HAVE REPLACED EVERYTHING ON IT TWICE. I JUST GOT IT OUT OF THE SHOP YESTERDAY AGAIN FOR THE THOUSANDS TIME AND NOW THE TRACTION CONTROL LIGHT THE BRAKE LIGHT THE TIRE LIGHT ON THE DASH IS ON. THIS CAR IS A NIGHTMARE. I HAVE PAID SO MUCH MONEY TO NEVER ENDING DRAMA. HELP I BEG YOU. THE CAR HAS CAUGHT ON FIRE DUE TO THE CLUTCH FLUID LEAKING EVERYTHING YOU CAN THINK HAS HAS BEEN REPLACED.TALK ABOUT A LEMON. NO LEMON LAW WILL HELP. *TR

Jan 02, 2014

Fire: 1

CAR STARTS BUCKING, CHECK ENGINE LIGHT COMES ON, WHITE SMOKE BLOWING OUT EXHAUST, EVENTUALLY CAR DIES. DEALER STATES, 02 SENSOR IN BANK ONE FAILED. CAR HAS BEEN BACK TO DEALER FOR SAME FAILURE 5 TIMES IN A 4 MONTH PERIOD. P0131, P1133, P0300 AND P0171. PURCHASED VEHICLE JUNE 20, 2008 FIST ISSUE WAS JULY 15, 2008. VEHICLE WAS PURCHASED AS A GM CERTIFIED USED VEHICLE WITH LESS THEN 25000 MILES ON IT. GM CASE # 10447543. CAR WAS LAST IN THE SHOP 11/2008 AND HAS BEEN PUT IN MY GARAGE FOR THE WINTER. WILL NOT KNOW IF PROBLEM HAS BEEN RESOLVED UNTIL SPRING. *TR

Feb 07, 2009

2006 CHEVROLET CORVETTE Z06 OIL LINE RELATED ENGINE FIRE CUSTOMER STATES THAT THIS SEEMS TO BE A KNOWN PROBLEM**CC THE CONSUMER STATED ON JUNE 8, 2007 HIS NEW CAR SUSTAINED A 3 POINT ENGINE FIRE RELATED TO AN ENGINE OIL LINE DEFECT. THE CONSUMER HE STATED WAS ACCOMPANIED BY EXPERIENCED GM CERTIFIED MECHANIC WHO ASSESSED FOR UNRELATED REPAIRS AND WARRANTY WORK. THE CONSUMER STATED THE MECHANIC MADE AN ANALYSIS AS TO WHAT CAUSED THE FIRE. ANALYSIS REVEALED A DEFECTIVE OIL LINE AT THE CRIMPED- ON RUBBER HOSE TO METAL INTERFACE WHICH CONDUCTS OIL TO AN EXTERNAL COOLER. *TR

Jul 23, 2007

Fire: 1

ELECTRONIC STABILITY CONTROL (ESC),TRACTION CONTROL SYSTEM

3 complaints

WHILE DRIVING IN A STRAIGHT LINE AT APPROXIMATELY 65 MPH, THE TRACTION CONTROL SYSTEM STRONGLY APPLIED THE LEFT FRONT BRAKE. THE APPLICATION OF BRAKE WAS SUDDEN AND VERY STRONG, NEARLY CAUSING A LOSS OF CONTROL. *TR

Oct 21, 2013

APPROXIMATELY ONE YEAR AGO, MY 2006 CORVETTE STARTED SHOWING THREE MESSAGES: SERVICE ACTIVE HANDLING/SERVICE TRACTION CONTROL/SERVICE ABS. I WAS GOING TO HAVE THE DEALER TAKE A LOOK AT THE VEHICLE, BUT THEN THE MESSAGES WENT AWAY. THEY WOULD COME ON AND OFF, BUT IT WAS NOT A VERY FREQUENT OCCURRENCE. YESTERDAY, 07/28/2013, NOT ONLY DID THE MESSAGES APPEAR, BUT MY ABS KICKED IN WHILE GOING AROUND A CORNER AND I ALMOST LOST CONTROL OF MY VEHICLE. I SHUT DOWN THE VEHICLE AND RESTARTED IT, BUT ALL THREE MESSAGES CAME BACK ON WITHIN 30 SECONDS OF DRIVING IT. I NO LONGER FEEL SAFE DRIVING MY 2006 CORVETTE WITH ONLY 40,000 MILES ON IT. *TR

Jul 29, 2013

WHEN DRIVING THE SERVICE ACTIVE HANDLING SYSTEM WARNING LIGHT APPEARS ON THE DASH. I HAVE HAD THE ORIGINAL RECALL FIX PERFORMED ON MY CAR (ORANGE/RED CLIP) AND HAD THE STEERING WHEEL POSITIONING SENSOR REPLACED. THE PROBLEM IS NOW BACK AGAIN. *TR

Jun 01, 2011

TRACTION CONTROL SYSTEM

3 complaints

MY ACTIVE HANDLING COMES ON FOR NO APPARENT REASON IN MY CORVETTE CAUSING IMMEDIATE UNCONTROLLABLE BRAKING. IT RESULTS IN SWERVING AND DANGEROUS CONDITIONS. *TT

Jul 11, 2011

I PURCHASED A 2006 CORVETTE IN JUNE OF 2010. SINCE THEN I HAVE HAD VARIOUS ELECTRICAL PROBLEMS INCLUDING, HIGH AND LOW TIRE PRESSURE WARNINGS, FLAT TIRE WARNING (TIRES WERE FINE), SERVICE ACTIVE HANDLING SYSTEM (HAS HAPPENED TWICE WHILE DRIVING, FRONT TIRES LOCKED UP.. ALMOST GOT REAR ENDED. I WAS SITTING AT A LIGHT, WHEN TO TURN LEFT AND FRONT TIRES LOCKED UP. PUSHED THE CLUTCH IN SEVERAL TIMES BUT TIRES STILL LOCKED UP. TURNED OFF THE ACTIVE HANDLING .. CHOSE COMP DRIVE MODE, PROBLEM WENT AWAY. SEVERAL TIMES LATELY THE PUSH BUTTON START DOES NOT START THE ENGINE, EVERYTHING ELSE COMES ON BUT NOTHING FROM THE ENGINE. CHANGE TO A DIFFERENT GEAR, PUSH CLUTCH BACK IN, NOTHING.. AFTER SEVERAL ATTEMPTS, IT FINALLY 'CATCHES" AND STARTS. THE TIRES HAVE LOCKED UP TWICE SINCE JUNE OF 2010. THE PUSH BUTTON START BEGAN MALFUNCTIONING ON A DAILY BASES ABOUT 3 WEEKS AGO. I DO NOT WISH TO FLY OFF THE HIGHWAY INTO A DITCH BEFORE THIS CAN BE FIXED. (ACTIVE HANDLING). *TR

Jan 31, 2011

I OWN A 2006 CHEVY CORVETTE. I FIRST GOT THE SERVICE ACTIVE HANDLING LIGHT WHEN I BOUGHT MY CAR USED AT 31K MI. I TOOK IT IN FOR SERVICE AND THE DEALER FIXED THE ISSUE BY PUTTING THE PLASTIC CLIP IN THE SWPS PLUG, AS LISTED IN THE TSB. APPROX 10 MONTHS LATER THE SERVICE ACTIVE HANDLING CAME BACK ON. IT COMES ON SOMETIMES AND NOT OTHERS. FORTUNATELY NONE OF MY WHEELS HAVE LOCKED UP BUT I AM WORRIED FOR MY SAFETY AND MY FAMILIES SAFETY. OF COURSE MY CAR IS OUT OF WARRANTY( 900 MILES OUT) AND I HAVE TO PAY TO SOLVE THIS PROBLEM ON MY OWN DOLLAR AND WORRY THAT THE WHEELS COULD LOCK UP. *TR

Sep 08, 2010

ELECTRICAL SYSTEM,ENGINE

2 complaints

We were driving 55 and the car stalled. This has happened several times. Been at dealer and the codes show fine they replaced what they thought was issue and it still does this. Very scary

May 11, 2025

VALVE RATTLE, NOT DRIVING VEHICLE TO KEEP FROM DROPPING VALVE......COSTS $4K FOR REPAIR TO HEADS....31000 MILES... IF I DRIVE IT AND DROP VALVE, WILL COST $18K TO REPLACE ENGINE ASSEMBLY.....LONG TERM VALUE OF VEHICLE DECREASES WITH NON-MATCHING NUMBERS VEHICLE. ONE HELLUVA WAY TO TREAT CUSTOMERS THAT SPEND $85K ON A VEHICLE.

Nov 21, 2017

SEATS

2 complaints

This is a 2006 Corvette with roughly 82,000 miles. The driver's seat will intermittently collapse on the recline function, resulting in a seat that is reclined all the way back. When this occurs, I need to pull myself up by the steering wheel while the vehicle is going down the road.

Jul 11, 2023

THE DRIVER'S SIDE METAL SEAT FRAME WAS SHATTERED INTO 3 PLACES. THE SEAT WOULD NOT RECLINE PROPERLY, AND AS I WAS TOLD BY THE DEALER WHEN I TOOK IT IN TO BE FIXED: THE SEAT WAS FLOATING LOOSELY IN THE CAR WHEN IT ARRIVED AT HIS SHOP. THE CORVETTE HAD ONLY 29,900 MILES ON IT, WAS NOT A DAILY DRIVER, AND HAD ONLY SEEN RECREATIONAL WEEKEND USE. THE CORVETTE WAS NEVER IN AN ACCIDENT, ALWAYS GARAGED, AND WELL TAKEN CARE OF. AS AN AEROSPACE ENGINEER, I STRONGLY BELIEVE THERE WAS A MANUFACTURING DEFECT IN THE SEAT FRAME THAT LED TO THIS FAILURE. THE SEAT HAD ONLY SEEN 29,900 MILES OR LESS OF REGULAR, EVERY DAY USE BEFORE THE FAILURE OCCURRED. THAT LEADS ME TO BELIEVE THERE WERE HAIRLINE FRACTURES IN THE METAL SEAT FRAME BEFORE IT WAS INSTALLED IN MY CORVETTE AT THE ASSEMBLY PLANT. FAILURES IN BOTH THE SUPPLIER'S MANUFACTURING PROCESS AND CHEVROLET'S QUALITY INSPECTION PROCESS OCCURRED IN THIS INSTANCE. HAD I BEEN IN AN ACCIDENT WITH A SEAT THAT WAS NOT SECURED TO THE CORVETTE, THE INJURIES I WOULD HAVE SUSTAINED WOULD HAVE BEEN SIGNIFICANT. I FILED A COMPLAINT WITH CHEVROLET ABOUT THIS, AND BELIEVE THE COMPLAINT DID NOT RECEIVE THE ATTENTION THAT IT SHOULD HAVE RECEIVED. THERE WAS NO ACKNOWLEDGEMENT OF AN INVESTIGATION INTO THE FAILED PART, AND I WAS ONLY PARTIALLY REIMBURSED FOR THE COST OF REPAIR. AS A RESULT, I AM FILING A SEPARATE COMPLAINT WITH THE GOVERNMENT SO THEY CAN PROVIDE THE PROPER OVERSIGHT IN THIS MATTER. REPAIRS WERE MADE TO THE VEHICLE, AND I WAS CHARGED BECAUSE THE REPAIRS WERE DEEMED BY CHEVROLET TO BE OUT OF BOTH THE 3 YEAR/36,000 MILE WARRANTY DUE TO TIME (THE CORVETTE WAS 4 YEARS OLD), AND THE AND THE EXTENDED (GMPP) 5 YEAR/60,0000 MILE BUMPER TO BUMPER NO DEDUCTIBLE WARRANTY THAT I HAD PURCHASED FOR $1700 DUE TO THE FACT THAT, AS CHEVROLET SAID, BEING "NOT COVERED UNDER THE EXTENDED BUMPER TO BUMPER WARRANTY" I HAD PURCHASED FOR EXTRA. *TR

Sep 26, 2010

FUEL SYSTEM, GASOLINE

2 complaints

OVERWHELMING FUEL ODOR AFTER SHUTTING CAR OFF AND HOUSING IT IN THE GARAGE OR OUTSIDE. ESPECIALLY NOTICEABLE IN SUMMER WHEN ETHANOL IS ADDED TO FUEL - HEAVY SMELL OF NAIL POLISH REMOVER INSIDE AND OUTSIDE THE CAR. FUEL VAPOR LEAK FROM GAS TANK REQUIRES $2,678.87 REPAIR. FUEL VAPOR BUILDUP INSIDE THE VEHICLE AND/OR GARAGE AND HOUSE ARE A FIRE HAZARD AS WELL AS A HEALTH HAZARD. OTHER OWNERS HAVE COMPLAINED OF SIMILAR PROBLEM ON THE CORVETTE FORUM. CHEVROLET NEEDS TO RECALL AND REPLACE THIS COMPONENT ON ALL C6 CORVETTES. *BF *TR

Aug 10, 2018

FAINT FUEL ODOR AFTER SHUTTING CAR OFF AND HOUSING IT IN THE GARAGE. FUEL VAPOR OR VERY SMALL LINK FROM GAS TANK IS SUSPECTED. OTHER OWNERS HAVE COMPLAINED OF SIMILAR PROBLEM ON THE CORVETTE FORUM. *TR

May 08, 2012

POWER TRAIN,FUEL/PROPULSION SYSTEM

2 complaints

HAS CRACK ON TOP OF FUEL PUMP SPRAYING GAS , SMELLS IN CAB

Feb 05, 2016

ON AUGUST 13, 2015, MY 2006 CORVETTE WOULD NOT SHIFT OUT OF REVERSE. THE CAR WAS STUCK IN THAT REVERSE GEAR AND THE SHIFT LEVER WAS NOT ENABLING THE SELECTION OF ANOTHER GEAR. THE SHIFTER MECHANISM ON THIS AUTOMATIC EQUIPPED VEHICLE WAS OPERATIONAL, BUT THE LINKAGE TO THE TRANSMISSION WAS NO LONGER ENGAGED. THE CAR WAS BEING PULLED INTO THE GARAGE WHEN THIS HAPPENED, SO FORTUNATELY I WAS NOT IN A BUSY INTERSECTION, IN A PARKING LOT, OR IN SOME OTHER LOCATION WHERE I, OR SOMEONE ELSE, MIGHT HAVE BEEN IN HARM'S WAY DUE TO A VEHICLE THAT I COULD NO LONGER CONTROL. SINCE THE CAR COULD NOT BE PUT IN NEUTRAL OR PARK, I HAD TO TURN OFF THE VEHICLE WITH IT IN REVERSE AND USE THE PARKING BRAKE TO KEEP THE CAR FROM MOVING. SINCE THE SHIFTER MECHANISM COULD STILL MOVE, THE SWITCH ACTIVATING THE "OK TO START" WOULD HAVE ALLOWED THE CAR TO START WHEN PUT IN THE PARK OR NEUTRAL POSITIONS - WHILE THE TRANSMISSION WAS STILL STUCK IN REVERSE; A REAL SAFETY ISSUE. THE CAUSE OF THE PROBLEM WAS A 50 CENT BUSHING THAT ATTACHES TO THE SHIFT LEVER. THIS BUSHING ALLOWS THE BALL END CONNECTOR OF THE SHIFTER TO ENGAGE A SHIFTER CABLE THAT ACTUATES THE LINKAGE TO THE TRANSMISSION. SO WHEN THAT BUSHING BREAKS, YOU CAN NO LONGER SHIFT THE CAR. THIS HAS HAPPENED TO MANY, MANY PEOPLE OWNING THE GENERATIONS OF C5 (1997-2004) AND C6 (2005-2013) CORVETTES. YOU CAN READ A SAMPLE THREAD WITH PICTURES HERE: HTTP://WWW.CORVETTEFORUM.COM/FORUMS/C6-CORVETTE-GENERAL-DISCUSSION/3482107-C6-AUTOMATIC-SHIFTER-BROKEN-NEED-HELP-REPLACING-TRANSMISSION-SHIFTER-MODULE.HTML OR HERE (AND THERE ARE MANY MORE!) HTTP://WWW.CORVETTEFORUM.COM/FORUMS/C5-GENERAL/2684621-BROKEN-SHIFTER-LINKAGE-FIX-WITH-PICS.HTML THE PART REPLACED (THE BUSHING) FAILED BECAUSE OF PLASTIC DETERIORATION, THE PICTURES IN THE ABOVE LINKS SHOW THE BROKEN PART AND THE PART OBTAINED TO REPAIR THE PROBLEM. THIS PROBLEM NEEDS SERIOUS ATTENTION!

Aug 15, 2015

ELECTRICAL SYSTEM,UNKNOWN OR OTHER

2 complaints

AUTO SHIFTER GETS STUCK IN PARK. SHIFTER LOCK WILL NOT DISENGAGE WHEN DEPRESSING THE BRAKE PEDAL.

Jan 05, 2016

CAR WILL NOT SHIFT OUT OF PARK. MANY OWNERS HAVE THE SAME PROBLEM. THE SHIFT LOCK SOLENOID FAILS AND YOU CANNOT GET CAR INTO GEAR.

Dec 13, 2015

WHEELS

2 complaints

WHEN THE VEHICLE BE IN 1ST GEAR , IT MAKES A WEIRD NOISE, I TOOK IT TO THE DEALERSHIP,THEY REPLACED A SCREW ON THE REAR END BUT IT DID NO SOLVE THE PROBLEM. THE CAR ONLY HAS 16000 MILES ON IT NOW. I CALLED THE CAR MANUFACTURE SHE SAID IT WASNT NOTHING THEY CAN DO. IM AFRAID THE REAR END MIGHT FALL OFF.

Sep 27, 2015

I WAS DRIVING DOWN THE ROAD AND HIT A SMALL POT HOLE. THE ALLOY RIM OF MY NEW C6 CORVETTE SPLIT IN HALF AROUND THE CIRCUMFERENCE CAUSING PARTIAL LOSS OF CONTROL IN TRAFFIC. SPEED WAS APPROXIMATELY 40 TO 50 MPH. IT APPEARS THE WHEEL INDUCTION WELDING IS FLAWED. I FEAR OTHER WHEELS HAVE THE SAME FLAW. AT SPEED, THIS COULD BE THE CAUSE OF A FATAL ACCIDENT. I AM A MECHANICAL ENGINEER AND IT APPEARS FLAWED TO ME. I HAVE THE WHEEL IN MY POSITION AND I HAVE PICTURES I CAN EMAIL.*JB

Mar 09, 2006

POWER TRAIN,ELECTRICAL SYSTEM

2 complaints

CAR WOULD NOT SHIFT OUT OF PARK. *TR

Apr 23, 2015

CAR STICKS IN PARK. WILL NOT GO IN GEAR. *TR

Apr 18, 2014

SERVICE BRAKES, HYDRAULIC

2 complaints

I WAS PULLING OUT OF A DRIVEWAY ONTO A MAIN ROAD MAKING A LEFT TURN. SUDDENLY MY FRONT BRAKES GRABBED WITH FULL FORCE AND STOPPED THE CAR. THE ACTIVE HANDLING LIGHT CAME ON. I STEPPED ON THE GAS HARD AND OVER POWERED THE BRAKES TO MOVE THE CAR TO THE SIDE OF THE ROAD. I TURNED OFF THE CAR WAITED A MINUTE AND RESTARTED THE VEHICLE. THE ACTIVE HANDLING LIGHT WENT OFF AND I WAS ABLE TO DRIVE NORMALLY AGAIN. IT WAS RAINING AND ABOUT 60 DEGREES AT THE TIME. I AM THE SECOND OWNER OF THE CAR AND THIS IS THE ONLY TIME IT HAS HAPPENED IN THE YEAR I HAVE OWNED IT. I SAW A BULLETIN ABOUT THIS PROBLEM FOR MANY 2006 CHEVROLET CORVETTES AND DECIDED TO SEND THIS LETTER ABOUT IT. I NEVER BROUGHT THE CAR IN FOR SERVICE BECAUSE I THOUGHT IT WAS A TEMPORARY MALFUNCTION. *TR

Oct 27, 2009

6 MONTHS AGO MY SERVICE ACTIVE HANDLING SYSTEM LIGHT CAME ON WENT TO DEALER THEY SAID IT WAS NO BIG DEAL AND SHUT THE LIGHT OFF, A MONTH LATER BACK ON ,SAME THING FROM THE DEALER NOW SUNDAY 7/19/2009 WITH MY SON IN THE CAR AT 55MPH LIGHT CAME ON CAR DARTED RIGHT LUCKY I SAVED IT SHUT THE CAR OFF WHEN WE STARTED BACK HOME IT WAS OFF BUT SOON CAME BACK ON SINCE THEN THIS HAS HAPPENED FOUR TIMES. CALLING THE DEALER TODAY 2006 CORVETTE COUPE MANUAL TRANS W/27K ON IT. *TR

Jul 20, 2009

VISIBILITY

2 complaints

BOUGHT USED 06 CORVETTE. BROUGHT CAR IN TO GM DEALER FOR REPAIR OF REAR WINDOW SINCE MY TINT INSTALLER SAID WINDOW WAS DEFECTIVE. I ALSO NOTICED THE IMAGES THROUGH THE WINDOW ARE BLURRED BADLY. THE TINT APPEARS TO CLARIFY THE IMAGES. DEALER SAID MUST SEE GM REP FOR REPLACEMENT. NOTICED ANOTHER 06 CORVETTE HAD SAME BLURRED REAR WINDOW, HOWEVER THE 09 CORVETTE REAR WINDOW IS IMPROVED BUT STILL CREATES BLURRED VISION. *TR

Jun 08, 2009

TL* THE CONTACT OWNS A 2006 CHEVROLET CORVETTE. THE VISIBILITY IN THE REARVIEW MIRROR WAS DISTORTED AND BLURRED. THE DEALER STATED THAT EVERY OTHER CORVETTE WAS AFFECTED AND THERE WAS NOTHING THAT THEY COULD DO ABOUT IT. THEY DID NOT SPECIFY THAT THIS WAS RELATED TO ANY RECALLS. THE FAILURE MILEAGE WAS 15, AND THE CURRENT MILEAGE IS 2,085. *AK UPDATED 05/23/07. *JB

Apr 30, 2007

ELECTRICAL SYSTEM,EXTERIOR LIGHTING,SERVICE BRAKES

1 complaint

The contact owns a 2006 Chevrolet Corvette. The contact stated while driving at speeds above 25 MPH, the ABS system failed, causing the front brakes to activate without the driver depressing the brake pedal. During the failure the active handling warning light was illuminated. The vehicle was taken to an independent mechanic who diagnosed that the active handling control module wiring harness was faulty and needed to be replaced. Additionally, while operating the vehicle the low beam headlights inadvertently turned off. The mechanic diagnosed that the wiring harness for the exterior lighting needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure. The contact was informed that the vehicle was previously repaired under NHTSA Campaign Number: 14V251000 (Electrical System, Exterior Lighting). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 50,000. The contact stated that he pulled the fuse box and wiring from the car. In the photos, we can see a damaged wire around a tight bend that has created tension and caused a faulty connection.

Sep 19, 2023

POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

1 complaint

Happened twice within a day. The main electric fan on the radiator stopped working and the car overheated. Once at idle, was able to shut the car off safely. The second time, there was traffic on the highway, and the fan stopped working and the car started to overheat. Had to shut the car off and wait for it to cool down on the side of the road. When I got the car home, I found the electrical connector of the fan to be melted and fused together. There was no indicator that the fan would stop running prior to the engine overheating.

Aug 14, 2023

SERVICE BRAKES, AIR

1 complaint

The service active handling and the traction control error is appearing on my cars instrument panel. Causing the cars ABS system to activate the front brakes while driving.This reaction causes the car to pull to the left, nearly causing an accident. It has random affected my car here recently. In that years that I have owned the car I have not had an issue. However, I see that this issue has been widely reported on this generation. Although I don’t see a recall for this issue. I do see that this is very dangerous. I feel lucky that this did not happen as I was traveling at a higher rate of speed or I probably would have wrecked the car.

May 08, 2022

STEERING,SUSPENSION,SERVICE BRAKES

1 complaint

2006 CORVETTE, VIN IS [XXX] APPROXIMATELY 10 TIMES WHILE DRIVING ANYWHERE FROM 5 MPH TO 75 MPH THE STEERING WHEEL JERKS THE VEHICLE THE LEFT.......ALMOST CAUSING AN ACCIDENT MANY TIMES BY PULLING ME INTO THE MEDIAN. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Aug 19, 2020

STEERING,SEATS,SERVICE BRAKES

1 complaint

RECENTLY WHEN I MADE A TURN IN FRONT OF ON COMING TRAFFIC THE CORVETTE STEERING DID NOT RETURN TO CENTER I ALMOST HIT HE VEHICLE AT THE STOP SIGN !!!!!! I ALSO NOTICE THE ABS LIGHT ON

Sep 24, 2019

ELECTRICAL SYSTEM,EXTERIOR LIGHTING,VISIBILITY/WIPER

1 complaint

THE FRONT LIGHTS OF THE CAR ONE OF THEM ISN'T WORKING. I BELIEVE THIS ISN'T THE FIRST COMPLAIN ABOUT THIS KIND OF CAR. IT IS DANGEROUS TO BE DRIVING ON THE ROAD. I HAVE TO CONTINUE TO PUT MY HIGH BEAMS ON FOR THEM TO WORK. AT TIMES BOTH THE LIGHTS ARE ON AND WITH TIME DRIVING IT WILL TURN ONE OF THEM OFF. IT'S DANGEROUS BECAUSE THE VISIBILITY ON THE ROAD FOR ME AND OTHER DRIVERS.

Mar 22, 2019

POWER TRAIN,ELECTRICAL SYSTEM,UNKNOWN OR OTHER

1 complaint

MY AUTOMATIC SHIFTER JAMMED IN THE D LOCATION AND WOULD ONLY GO TO NEUTRAL AND WOULD NOT GO INTO REVERSE OR PARK, AND THE DOORS WOULD NOT OPEN WITH THE BUTTON, THIS SHIFTER HAS JAMMED IN PARK IN THE PAST. THIS CAR ONLY HAS 26K MILES ON IT. AND IS NOT DRIVEN IN BAD WEATHER. NOT A GOOD FEELING TO BE TRAPED IN YOUR CAR.

May 02, 2018

EXTERIOR LIGHTING,ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES

1 complaint

MY ELECTRONIC STABILITY CONTROL COMES ON REGULARLY ESPECIALLY WHEN I HIT SAND IN DRIVEWAY AND TIRE SPINS WHICH I EXPECT BUT AT OTHER TIMES THE WARNING LIGHT COMES ON WITHOUT ANY TIRE SPIN OR CONDITION THAT WOULD WARRANT THIS. TURNING FROM A STAND STILL IS ANOTHER TIME THE LIGHTS WILL COME ON WITHOUT ANY TIRE SPIN. MY WIFE DRIVES THIS CAR NOW AND I GOT A NEWER ONE. I AM WORRIED ABOUT HER SAFETY AS SHE IS AN OLDER LADY [XXX] AND IF BRAKES LOCKED UP OR STEERING SHE WOULD NOT KNOW HOW TO HANDLE THE SITUATION.

Jul 20, 2016

STEERING,ELECTRICAL SYSTEM,SERVICE BRAKES

1 complaint

TL* THE CONTACT OWNS A 2006 CHEVROLET CORVETTE. WHEN THE ENGINE WAS STARTED, A "SERVICE ACTIVE HANDLING" MESSAGE APPEARED ON THE INSTRUMENT PANEL. THE ERROR MESSAGE WAS CLEARED BY THE CONTACT. WHILE DRIVING AT ANY SPEED, THE BRAKES ACTIVATED INDEPENDENTLY. THE VEHICLE WAS PULLED OVER. THE VEHICLE WAS NOT TAKEN TO A MECHANIC. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 10V172000 (STEERING). THE FAILURE MILEAGE WAS UNKNOWN.

Jul 11, 2016

TIRES,EQUIPMENT

1 complaint

TL* THE CONTACT OWNS A 2007 CHEVROLET CORVETTE EQUIPPED WITH FOUR AFTERMARKET MHT F350 NITROUS SEC WHEELS. THE CONTACT STATED THAT THE INNER WHEEL FAILED, WHICH CAUSED THE TIRES TO PUNCTURE AND BENT THE RIMS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE DRIVER SIDE TIRE AND WHEEL. THE CONTACT STATED THAT FOUR TIRES FLATTENED DUE TO THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 58,000. THE VIN, SERIAL NUMBER, AND PART NUMBER WERE NOT AVAILABLE. UPDATED 5/28/15 *TA UPDATED 11/23/2015*JS

Apr 06, 2015

ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

HELLO, I AM REPORTING ON MY 2006 C6Z06 CORVETTE THAT RECENTLY HAD THE VALVE-TO-GUIDE CLEARANCES CHECKED ON MY ENGINE AND MY MEASUREMENTS ARE BEYOND THE SERVICEABLE SPECIFICATIONS ON 8 OUT OF 16 VALVES, BOTH INTAKE AND EXHAUST. I CONSIDER THIS A SAFETY HAZARD DUE TO THE FACT THAT IF THE VEHICLE IS DRIVEN AND ENGINE SEIZES, LOSS OF CONTROL MAY OCCUR. I ALSO HAVE WHAT APPEARS TO BE A LEAK ON THE FUEL MODULE/SENDING UNIT, SPECIFICALLY ON THE TOP PLASTIC ELBOW CONNECTOR. I HAVE STRONG GASOLINE ODOR IN THE CABIN OF THE CAR AND VISIBLE GASOLINE FROM THE UNDERSIDE OF THE CAR NEAR THE FUEL TANK. *TR

Jan 26, 2015

ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES

1 complaint

"SERVICE ACTIVE HANDLING SYSTEM" AND "SERVICE VEHICLE SOON" LIGHT BOTH CAME ON TODAY. RESEARCHED ON-LINE AND DETERMINED THAT THIS IS A VERY DANGEROUS ISSUE, POTENTIALLY FATAL. *TR

Nov 12, 2014

ELECTRICAL SYSTEM,STRUCTURE,ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

FIRST THE ROOF BLEW OFF.THE COMMUNICATION MESSAGE CENTER GIVES MIS INFORMATION.THE CAR HAS ALWAYS MADE A GRINDING SOUND UNDER HOOD AT START UP.PROBLEMSM ACTIVATING EELECTRICAL STABILITY SYSTEM.ALSO AFTER ROOF REPAIR ROOF RATTLES AND ALWAYS SOUND LOOSE. *TR

Aug 25, 2014

Crash: 1

Injuries: 1

STEERING,UNKNOWN OR OTHER,ENGINE

1 complaint

THE HARMONIC DAMPER ON 2006 CORVETTE WITH LS2 ENGINE FAILED RESULTING IN POWER STEERING DRIVE BELT COMING OFF PULLEY CAUSING LOSS OF POWER STEERING. THE HIGH EFFORT REQUIRED TO STEER VEHICLE ALMOST RESULTED IN CRASH. THIS HARMONIC DAMPER ISSUE IS DOCUMENTED IN NUMEROUS INTERNET FORUMS AND IS BELIEVED TO BE A WIDESPREAD ISSUE THAT SHOULD BE RECALLED AND CORRECTED BY THE MANUFACTURER. *JS

Jul 06, 2014

SERVICE BRAKES, HYDRAULIC,EQUIPMENT ADAPTIVE/MOBILITY

1 complaint

ACTIVE HANDLING WARNING LIGHT CAME ON AND THE CAR SUDDENLY PULLED TO THE RIGHT WITH NO WARNING AND PUT THE RIGHT FRONT BRAKE ON. *TR

Jul 19, 2013

ELECTRICAL SYSTEM,SERVICE BRAKES

1 complaint

ACTIVE HANDLING SYSTEM APPEARED AND MY BRAKES FELT DIFFERENT. THE CAR IDLED DIFFERENTLY TOO. FELT LIKE IT WAS MISSING A CYLINDER. I BELIEVE THIS IS AN ONGOING PROBLEM AND IS DANGEROUS. *TR

Jul 10, 2013

EQUIPMENT ADAPTIVE/MOBILITY,ENGINE

1 complaint

ACCORDING TO CORVETTE FORUM, THIS IS ANOTHER WIDESPREAD PROBLEM- THE HARMONIC-BALANCER BECOMES WARPED AND REQUIRES REPLACEMENT... IF NOT DONE TIMELY, OTHER "PARTS" COULD BE NEGATIVELY IMPACTED AS WELL... *TR

May 15, 2013

STEERING,SUSPENSION

1 complaint

WHILE DRIVING THE CAR THE ACTIVE HANDLING COMES ON THEN THE CAR PULL TO ONE SIDE (RIGHT) VERY HARD THEN RELEASE. *TR

Nov 26, 2012

AIR BAGS,TIRES,ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

ON WEDNESDAY 7 NOV 2012, I WAS DRIVING HOME FROM WORK AT APPROX 4:30PM AND WHILE CHANGING LANES (FROM THE RH LANE TO THE LH LANE, TO MAKE A LEFT TURN IN APPROX HALF A MILE) WHEN THE FRONT DRIVER'S SIDE TIRES POPPED AND I SPUN, CROSSED THE MEDIAN, CROSS TWO SOUTHBOUND LANES, STRUCK AN ELECTRICITY POLE, SPUN AGAIN AND FINALLY CAME TO REST ON THE SIDEWALK & GRASS. NEITHER STABILITY CONTROL NOR TRACTION CONTROL ACTIVATED ONCE THE CAR BEGAN TO SPIN (COUNTER CLOCKWISE) WHICH CREATED AN UNCONTROLLABLE AND UNRECOVERABLE SPIN. THE FAILURE OF THESE SYSTEMS ACTIVATE AND OPERATE PROPERLY COULD HAVE KILLED ME AND DESTROYED THE CAR. BOTH SYSTEMS WERE FULLY OPERATIONAL AND ON. ALSO, THE SIDE AIRBAG DID NOT DEPLOY WHEN THE IMPACTED THE POLE ON THE DRIVER'S SIDE DOOR. *TR

Nov 09, 2012

Crash: 1

ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM

1 complaint

2006 CHEVROLET CORVETTE. CONSUMER STATES LOSS OF HEADLAMPS WHEN ENGINE HEATS UP. *TGW

Jul 26, 2011

WHEELS,ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

I OWN A 2006 CORVETTE AND WHILE DRIVING ON HIGHWAY 270 IN GERMANTOWN, MD THE RIGHT FRONT WHEEL OF THE CAR LOCKED UP FOR NO REASON. I WAS NOT BRAKING TURNING OR CHANGING SPEED. I WAS CRUISING AT A CONSTANT 60 MPH WHEN IT ALL OF A SUDDEN LOCKED UP THE FRONT RIGHT WHEEL. IT CAUSED THE CAR TO RUN OFF THE ROAD INTO THE SHOULDER! I WAS VERY LUCKY TO BE EXACTLY WHERE I WAS AT THE TIME OR SOMEONE MAY HAVE BEEN KILLED! I LOOKED INTO GM RECALL INFO AND FOUND THERE HAS BEEN 3 DIFFERENT FIXES FOR THIS PROBLEM. I ALSO FOUND THAT 2 OF THE 3 FIXES HAVE BEEN DONE TO THIS CAR BY THE PREVIOUS OWNER AND NEITHER FIX HAS WORKED. I AM BRINGING THE CAR INTO THE DEALER TOMORROW AFTER SOME QUICK RESEARCH I FOUND THIS PROBLEM TO BE VERY COMMON TO THE 2005-2008 CORVETTES. I CAN'T BELIEVE GM HAS DONE NOTHING ABOUT THIS! *TR

May 31, 2011

STRUCTURE,ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

WHILE DRIVING MY 2006 CORVETTE WITH 15,000 MILES IT SUDDENLY VEERED TO THE RIGHT PULLING THE CAR OFF THE ROAD. THE "CHECK STABILITY CONTROL SYSTEM" CAME ON THE IN DASH COMPUTER. *TR

Nov 06, 2010

STEERING,TRACTION CONTROL SYSTEM

1 complaint

2006 CORVETTE COUPE- FRONT LEFT TIRE LOCKED UP @ 35 MPH. THE RECALL CLIP HAD ALREADY BEEN INSTALLED BEFORE I PURCHASED THE CAR. THE TECH AT THE LOCAL GM DEALER CALLED GM.AND WAS TOLD TO REPLACE THE STEERING WHEEL POSITION SENSOR. *TR

Jul 08, 2010

STEERING,STRUCTURE

1 complaint

THERE IS 2 RECALLS ON MY 06 Z06 WHICH WAS BUILT IN 11/05. ! IS THE ROOF COMING OFF AND THE OTHER IS THE STEERING WHEEL POISONING SENSOR. I WAS IS CONTACT WITH THE NHTSA CAMPAIGN ID NUMBER : 10V172000 ON THIS. GM AND MY DEALER KEEPS TELLING ME MY CAR IS OUT OF WARRENTY. THIS ISN'T WARRANTY AND MY CAR HAS BOTH PROBLEMS AND THE DEALER HAS BEEN TOLD FOR 2 YRS ABOUT THESE PROBLEMS. *TR

May 12, 2010

STEERING,SERVICE BRAKES, HYDRAULIC

1 complaint

EA09-002 MY CAR SUDDENLY PULLS TO THE RIGHT OR LEFT AND BRAKES REALLY HARD SOMETIMES DURING NORMAL DRIVING, AND A SERVICE ACTIVE HANDLING LIGHT COMES ON. VERY DANGEROUS!! AFTER RESTARTING EVERYTHING SEEMS FINE UNTIL OUT OF THE BLUE IT HAPPENS AGAIN. *TR

Apr 09, 2010

SERVICE BRAKES, ELECTRIC

1 complaint

FOR THE PAST YEAR MY 2006 CORVETTE HAS PERIODICALLY DISPLAYED A WARNING ON THE DRIVER INFORMATION SCREEN WHICH READS "SERVICE VEHICLE SOON" FOLLOWED NEARLY IMMEDIATELY BY "SERVICE ACTIVE HANDLING SYSTEM." WHEN THE PROBLEM FIRST OCCURRED THE VEHICLE WAS UNDER WARRANTY WITH APPROXIMATELY 12,000 MILES. THE VEHICLE NOW HAS ROUGHLY 20,000 MILES AND IS OUT OF WARRANTY. THE VEHICLE HAS BEEN INTO OUR LOCAL CHEVROLET DEALER IN LIVERMORE, CA FIVE TIMES FOR THIS ISSUE (JAN 09, MAR 09, MAR 09, DEC 09, JAN 10) THE DEALER TRIED A NUMBER OF REPAIRS BUT THE WARNING CONTINUED. THE DEALER AND GM ARE NOW STATING THAT THE PROBLEM IS RELATED TO DEFECTIVE BPMV AND EBCM UNITS WHICH CONTROL THE ANTILOCK BRAKING SYSTEM AND THE STABILITRACK SYSTEM. THEY ARE REFUSING TO CORRECT THE PROBLEM. MY CONCERN IS THAT THIS IS APPARENTLY A CHRONIC PROBLEM FOR THESE VEHICLES WHICH COULD POTENTIALLY RESULT IN A SERIOUS INJURY OR DEATH IF THE BRAKES WERE TO LOCK UP AT THE WRONG TIME. *TR

Jan 21, 2010

EQUIPMENT

1 complaint

PUSH BUTTON START ON CORVETTE: NO WAY TO TURN OFF MOTOR IF GAS PEDAL STICKS OPEN. *TR

Dec 30, 2009

ELECTRICAL SYSTEM,TRACTION CONTROL SYSTEM

1 complaint

ABOUT 3 MONTHS AGO MY 2006 CORVETTE'S DIC SAID PLEASE SERVICE THE TRACTION CONTROL SYSTEM AND THE TRACTION CONTROL OFF INDICATION LIGHT CAME ON. LATER THAT DAY I WENT TO TAKE THE CAR TO BE SERVICED. ON THE WAY THE CHECK ENGINE LIGHT CAME ON BUT THE OTHER LIGHTS HAD GONE AWAY. AT THE DEALERSHIP IT WAS PLUGGED UP TO A COMPUTER I WAS TOLD IT SAID THERE WAS A LEAK FROM THE GAS CAP, WHICH DOESN'T CLOSE PROPERLY AT TIMES. I WAS ALSO TOLD THE COMPUTER SAID NOTHING ABOUT THE TRACTION CONTROL SYSTEM AND JUST TO WATCH IT AND COME BACK ANOTHER TIME IF I KEPT HAVING PROBLEMS WITH IT. THE WARNING MESSAGE OR LIGHT DIDN'T COME ON AGAIN FOR ABOUT 4-5 WEEKS. WHEN IT DID I WAS DRIVING THE CAR AND AFTER HITTING A BUMP THE LIGHT AND WARNING CAME ON. WHEN THE CAR WAS TURN OFF AND RESTARTED IT WOULD GO AWAY. I HAD NOT BEEN DRIVING IT OFTEN BECAUSE I HAD ANOTHER CAR. THE PAST WEEK I HAD TO DRIVE IT EVERY DAY TO WORK DUE TO IT NOW BEING MY ONLY CAR. THE LIGHT AND WARNING NOW COMES ON ALMOST EVERY TIME IT IS DRIVEN. THE CAR IS TELLING ME THE TRACTION CONTROL SYSTEM IS OFF, BUT WHEN YOU ARE DRIVING IT SOMETIMES PULLS THE CAR TO THE LEFT WITHOUT ME MOVING THE WHEEL. WHEN THIS HAPPENS THE BREAK MAKES A GRINDING NOISE AND IF YOU PLACE YOUR FOOT ON TOP OF THE BREAK IT FEELS AS THOUGH IT IS BEING PUMPING UP AND DOWN. TWO TIMES NOW WHILE DRIVING DOWN THE INTERSTATE TO WORK THE CAR HAS PULLED ITSELF OFF THE ROAD CAUSING ME TO ALMOST WRECK AND CAUSING OTHERS WRECK BEHIND ME. I HAVE SET UP AN APPOINTMENT FOR TOMORROW 11/17/2009 BEFORE GOING TO WORK BUT WAS TOLD THEY ARE UNSURE (EVEN THOUGH THIS IS MAJOR AND I HAVE AN EXTENDED WARRANTY) IF THEY WILL HAVE A RENTAL CAR SO I CAN GO TO WORK. IF THEY DON'T I WILL BE FORCE TO DRIVE MY CAR UNTIL THEY DO AND I CAN GET OFF WORK. I CAN'T LOSE MY PROFESSIONAL JOB OVER TRANSPORTATION. THIS REALLY UPSETS ME BECAUSE I HAVE NO OTHER CHOICE OF TRANSPORTATION AND IT PUTS NOT ONLY ME BUT OTHERS AT RISK BECAUSE THIS CAR WITH 33,000 MILES IS FAULTING. *TR

Nov 16, 2009

SUSPENSION

1 complaint

CHANGING LANES ON A BUSY AVENUE AT LUNCH TIME GOING ABOUT 30MPG CAR LOST CONTROL FROM THE BACK AND ENDED HITTING A ELECTRICAL POST. AFTER TAKING TO SHOP AND BEING REPAIRED WHICH TOOK OVER 6 MONTHS I RETURNED TO THE SHOP DUE TO A NOISE IN THE RIGHT REAR WHERE THE ACCIDENT OCCURRED AND FOUND THAT THE REAR AXLE WAS BROKEN. IT WAS DECIDED THAT THIS WAS THE CAUSE OF THE ACCIDENT. *TR

Oct 06, 2009

Crash: 1

EQUIPMENT,ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

DROVE THROUGH A TURN (RT HAND) EXITED TURN AT APPROX 45 MPH OR LESS,WENT STRAIGHT FOR APPROX 300 FEET AND CAR LOCKED UP RT FRONT AND LEFT REAR BRAKES CAUSING CAR TO GO INTO 4 WHEEL SLIDE (60 DEGREES FROM DIRECTION THAT WAS STRAIGHT) JUMPED OVER CURB SIDE WAYS (DRIVERS SIDE FACING CURB) WENT OFF ROAD,TIRES DUG IN AND CAR ROLLED OVER 3 TIMES,DESTROYING CAR. THERE ARE MANY COMPLAINTS ON THIS ACTIVE HANDLING ISSUE. CAR IS STILL IN MY GARAGE AND HAS BEEN INSPECTED BY A AUTOMOTIVE FORENSICS INVESTIGATOR. CAR IS 100% COMPLETE AND READY FOR ANY ONES INSPECTION INCLUDING GENERAL MOTORS. *TR

May 25, 2009

Crash: 1

SUSPENSION,SERVICE BRAKES, HYDRAULIC,EQUIPMENT

1 complaint

2006 CHEVROLET CORVETTE- SERVICE ACTIVE HANDLING LIGHT COMES ON, RIGHT FRONT BRAKE LOCKS WHEN TURNING RIGHT. DEALER INSTALLED A CLIP TO HARNESS UNDER STEERING COLUMN TO FIX. PROBLEM STILL EXISTS. *TR

Mar 09, 2009

POWER TRAIN,STRUCTURE

1 complaint

TL*THE CONTACT OWNS A 2006 CHEVROLET CORVETTE Z06. WHILE DRIVING 70 MPH, THE HARDTOP ROOF PANEL FLEW OFF. THE DEALER REPLACED THE ROOF PANEL UNDER WARRANTY. WHILE DRIVING 55 MPH, THE ROOF PANEL FLEW OFF AGAIN AND PUSHED THE HEADLINER DOWN. THE VEHICLE SWERVED INTO A CURB AND ALL FOUR RIMS WERE DAMAGED. THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 06V181000 (STRUCTURE:BODY:ROOF AND PILLARS). THE FAILURE MILEAGE WAS 8,000 AND CURRENT MILEAGE WAS 18,000. UPDATED 03/04/08. *LJ THE REAR DIFFERENTIAL WAS REPLACED. UPDATED

Feb 11, 2008

SEAT BELTS

1 complaint

TL* - THE CONTACT OWNS A 2006 CHEVROLET CORVETTE, AND STATED THAT THE SEAT BELTS WERE RETRACTING WITHOUT APPLYING THE BRAKES. ON ONE OCCASION, THE SEAT BELTS RETRACTED UNTIL THE SHOULDER PART OF THE BELT WAS ON THE CONTACT'S NECK AND HE FELT AS IF HE WAS BEING CHOKED. THE DEALER REPLACED THE SEAT BELTS, AND ADDED A SEAT BELT EXTENDER, BUT THE DRIVER CONTINUED TO EXPERIENCE THE FAILURE. THE CURRENT MILEAGE WAS 13,000 AND THE FAILURE MILEAGE WAS 1,500. *AK UPDATED 05/21/07. *JB

Feb 06, 2007

ELECTRONIC STABILITY CONTROL

1 complaint

THIS IS NOT ABOUT A SPECIFIC CAR, RATHER THERE HAVE BEEN SIX REPORTS THIS WEEK IN THE CORVETTE FORUM OF OWNERS WHO HAD THEIR ACTIVE HANDLING SYSTEM LOCK UP ALL FOUR WHEELS, PULSING VIOLENTLY AND MAKING THEIR CAR UNCONTROLLABLE. TWO OF THESE OWNERS REPORTED THIS HAPPENING AT ABOUT 40+ MPH AND HAD NO CONTROL OF THE CAR AS IT ENTERED ONCOMING TRAFFIC BEFORE COMING TO A STOP. THIS IS A VERY, VERY DANGEROUS SITUATION THAT COULD VERY EASILY TAKE THE LIVES OF DRIVERS AND PEDESTRIANS. *JB

Jun 05, 2006

2006 CHEVROLET Corvette Problems & Complaints

Complaints by Component

Frequently Asked Questions

How many problems does the 2006 CHEVROLET Corvette have?

What are the most common problems with 2006 CHEVROLET Corvette?

Where does this 2006 CHEVROLET Corvette problem data come from?

Other Years - CHEVROLET Corvette

Other CHEVROLET Models

Similar Brands