2020 CHEVROLET Corvette Problems

Complaints Reported

Complaints by Component

STRUCTURE

8 complaints

FRONT HOOD/TRUMP FLEW OPEN @ 20 MPH WHEN DRIVING THROUGH NEIGHBORHOOD. BENT THE LATCHES, DAMAGED THE HOOD AND QUARTER PANEL. LATCH IS FLIMSY AND LACKS BETTER LOCKING MECHANISM TO PROTECT IT FROM OPENING.

Sep 28, 2020

WHILE DRIVING AT 20-30 MPH, THE FRONT HOOD RELEASED AND THE HOOD OPENED TO A NEAR VERTICAL POSITION. AFTER STOPPING I CLOSED THE HOOD BUT IT TOOK A LOT OF EFFORT. WHEN CLOSED THE HOOD NOW IS RECESSED NEAR THE HINGES AND THERE IS SOME PAINT DAMAGE TO THE EDGES OF THE HOOD AND FENDERS. IT APPEARS THAT THE HINGES ARE DAMAGED. I IMMEDIATELY TOOK IT TO A DEALER AND THEY ARE TO RESEARCH THE ISSUE WITH CHEVY ENGINEERING. THE DAMAGE HAS BEEN REPAIRED UNDER WARRANTY. I AM CONCERNED THAT THIS MAY RE-OCCURE.

Aug 12, 2020

THE HOOD POPPED OPEN WHILE DRIVING DAMAGING THE CAR. FORTUNATELY THERE WERE NO OTHER CARS AROUND AND I WAS ABLE TO SAFELY PULL OVER. I WAS DRIVING AT 43MPH WHEN THE HOOD FLEW OPEN BLOCKING MY VISION AND DAMAGING THE CAR. I HAVE VIDEO OF THE INCIDENT FROM THE PERFORMANCE DATA RECORDER IN THE CAR. THE HOOD HAD NOT BEEN OPENED AT ALL THE DAY THIS OCCURRED AND I HAD DRIVEN ON MULTIPLE OTHER ROADS INCLUDING THE HIGHWAY WITHOUT INCIDENT. THE CAR HAD JUST OVER 1400 MILES ON IT AT THE TIME OF THE INCIDENT.

Aug 06, 2020

HOOD ON VEHICLE COULD COME UNLATCHED SINCE THERE IS ONLY ONE LATCH POINT, NO SAFETY LATCH. THE HOOD RELEASES TWICE AND COULD SPRING OPEN, CAUSING IMPAIRED VISION TO THE DRIVER, AND FLYING OBJECTS TO VEHICLE IN THE REAR,.IN ADDITION TO CAUSING EXTENSIVE VEHICLE DAMAGE..THERE HAVE BEEN AT LEAST 7 REPORTED ON THE CORVETTE FORUM. THE FORUM REPRESENTS ONLY A SMALL SAMPLE OF THE APPROX. 7000 VEHICLES PRODUCED TO DATE. I HAVE SECURED MINE USING HI TENSILE CORD., AWAITING A FIX FROM GM.

Jul 13, 2020

THE FRONT TRUNK OF THE VEHICLE FLEW OPEN WHILE DRIVING CAUSING BLOCKED VISIBILITY AND CREATED BENT HINGES FOR THE LID. THIS HAPPENED ON A CITY STREET AND DID NOT TAKE IT ON THE HIGHWAY AFTERWARDS FOR SAFETY REASONS

Jul 12, 2020

+ 3 more complaints for this component

POWER TRAIN

3 complaints

The contact owned a 2020 Chevrolet Corvette. The contact stated that while driving at an undisclosed speed, the contact came to a complete stop at a stop sign. The contact stated that the light turned green, the accelerator pedal was depressed, and the vehicle started jerking with a rumbling sound coming from the engine compartment. In addition, the engine independently shut off, however the transmission failed to properly shift, pressure level at zero, check engine light, idle creeping disabled, and service transmission warning lights illuminated. The contact stated that he restated the vehicle and the failure reoccurred, and the contact turned the vehicle off. The contact turned off and restarted the vehicle eleven times however, the failure persisted. The contact was able to restart the vehicle and drove to the residence. The vehicle was later towed to the dealer where it was diagnosed with a failed valve body. The contact was informed that the valve body needed to be replaced. The vehicle was repaired under warranty. The vehicle was sold to the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 7,200.

Dec 22, 2023

I had a complete transmission failure while on a road trip over July 4th. I just read that GM was doing a recall on the Transmission Control Module but it does not include my car, which is what failed on my car at 19,000 miles. My trip was interrupted, we spent two days paying for hotel & rental car in Springfield, MO and now my car is fixed with new TCU in Springfield, but I live in DFW area. If my car had a recall I would have had it fixed before our trip and this all could have been avoided. Now I have to figure out how to get my car back home.

Jul 08, 2023

AT THE TIME OF INCIDENT THE VEHICLE HAD 660 MILES. MOST OF THE ACCUMULATED MILES ARE: 60% STREET AND 40% HIWAY. I WAS INSPECTING THE WHEELS AND TIRE WHEN I SPOTTED A SIGNIFICANT AMOUNT OF GREY/BLACK COLORED GREASE RANDOMLY COVERING THE INNER WHEEL. UPON FURTHER INSPECTION I NOTICED THAT THE GREASE WAS SPLATTERED ON THE EMERGENCY BRAKE UNIT, SENSORS AND WIRING HARNESS. THE GREASE WAS ISOLATED TO THE REAR PASSANGER AXLE. I SUSPECT THAT THE GREASE CAME FROM A DEFECTIVE CV BOOT. TOOK VEHICLE IN TO CHECKOUT THE PROBLEM AND THEY DETERMINED THE GREASE WAS FROM A DEFECTIVE CV BOOT. NEW AXLE WAS ORDERED.

Dec 29, 2020

ENGINE

3 complaints

CAR IS EQUIPPED WITH REMOTE START. ON APRIL 20TH I PARKED IN THE GARAGE, PUT GROCERIES AWAY INCLUDING SOME THAT WENT IN THE FRIDGE IN THE GARAGE. THE CORVETTE KEYS WERE IN MY POCKET. I SET A TIMER FOR ONE HOUR FOR ITEMS I HAD PUT IN THE GARAGE FREEZER TO CHILL. WHEN I WENT BACK AT THE ONE HOUR ALARM, THE VEHICLE WAS RUNNING IN THE CLOSED GARAGE. TO USE REMOTE START THE VEHICLE HAS TO BE LOCKED FIRST AND I NEVER LOCK THE VEHICLE IN A CLOSED GARAGE. CHANCE MOTION OF THOSE KEYS IN MY POCKET HAD LOCKED THE VEHICLE AND INITIATED REMOTE ENGINE START. I HAD JUST LAID DOWN TO NAP WHEN THE ONE HOUR ALARM WENT OFF. I SHUDDER TO THINK WHAT WOULD HAVE HAPPENED HAD I NOT USED MY ALARM FOR THOSE FOOD ITEMS.

Apr 20, 2021

RECEIVED 2020 CORVETTE ON 9/15/20, ON 9/24/20 WENT TO USE THE CAR TO DO TO DOCTOR. THE CAR STARTED AND THEN WOULD NOT RUN. HAD ALL KIND OF MESSAGE; SERVICE ENGINE, NO OIL PRESSURE; TRACTION CONTROL, HAD BAD SMELL. HAD TO HAVE FLATBED TOW TRUCK GET THE CAR AND TAKE IT TO A CHEVROLET DEALER. CAR HAS BROKEN VALVE SPRINGS. CAR HAS BEEN GONE 10 DAYS SO FAR AND DO NOT HAVE ALL OF THE VALVE SPRINGS TO REPAIR CAR. CAR ONLY HAS 115 MILES ON IT. LUCKILY THE CAR WAS IN THE GARAGE WHEN THIS HAPPENED.

Oct 04, 2020

I TRIED TO REGISTER THE VEHICLE AND CANNOT REGISTER THE CAR. IT FAILS SMOG. 02 SENSOR NOT READY. THE BATTERY HAS NOT BEEN DISCONNECTED SINCE IT'S FIRST MILE DRIVEN.

Aug 04, 2020

SERVICE BRAKES

3 complaints

GM REFUSES TO REPLACE THE BRAKE MODULE DESPITE THE FACT THAT THIS HAS BEEN KNOWN SINCE SEPTEMBER 2020. THE REMEDY "IS INCOMPLETE"AND PARTS ARE NOT YET AVAILABLE. IT IS LUDICROUS TO ASSUME THAT PARTS ON A CURRENTLY PRODUCED CAR ARE NOT AVAILABLE. THEY ARE INSTALLING THIS MODULE DAILY. THESE ARE BRAKES THAT CAN FAIL AND CAN CAUSE AN ACCIDENT WHEN THEY DO FAIL.

Feb 22, 2021

ON SEPTEMBER 24, 2020, CHEVROLET ISSUED A RECALL FOR A POSSIBLE CONTAMINATED BRAKE BOOSTER MODULE ON NUMEROUS 2020 VEHICLES. THIS TO ME IS A SERIOUS MATTER WHEN IT DEALS WITH THE VEHICLES BRAKING SYSTEM. THERE HAVE BEEN CUSTOMERS ONLINE WHO HAVE TALKED ABOUT THIS ISSUE, WITH ONE CUSTOMER STATED THAT HIS BRAKES DID FAIL AND IT WAS DIFFICULT FOR HIM TO STOP. I HAVE MADE NUMEROUS CALLS TO GM AND NO ONE COULD GIVE ME ANY ACCURATE INFORMATION. I HAVE NOT BEEN DRIVING MY NEW 2020 CORVETTE VERY OFTEN BECAUSE OF FEAR OF BRAKE FAILURE. I WAS TOLD BY A GM REP THAT IF MODULE DID GO OUT THAT YOUR BRAKES WOULD STILL WORK. HE STATED THAT YOU WOULD JUST HAVE TO USE MORE FOOT PRESSURE ON BRAKES. IT HAS NOW BEEN OVER 90 DAYS AND I AM REQUESTING THAT THIS ISSUE GET RESOLVED FOR ALL NEW CAR OWNERS WHO HAVE THIS RECALL. GM IS TOO LARGE OF A COMPANY TO LET THIS JUST LINGER AS IF ITS NO BIG DEAL.

Dec 30, 2020

THIS COMPLAINT IS A RESULT OF GM NON ACTION TO THEIR RECALL A202307260. IT HAS BEEN 2 MONTHS SINCE THE RECALL HAS BEEN ANNOUNCED AND PARTS OR NOT AVAILABLE. LOSS THE THE AFFECTED ITEM (BRAKE BOOSTER) SEVERELY IMPACTS SAFETY THAT COULD CAUSE AN ACCIDENT RESULTING IN SEVERE INJURIES OR DEATH. GM HAS PARTS -- THEY ARE BUILDING 180 UNITS PER DAY. THERE ARE UNDER 700 - 2020 CORVETTE CARS AFFECTED BY THIS RECALL. GM IS PUTTING PROFIT AND SALES AHEAD OF SAFETY. NHTSA SHOULD REQUIRE GM TO IMMEDIATELY USE PRODUCTION PARTS TO REMEDY THIS ISSUE AND CLOSE THIS RECALL CONSIDERING IT IS SAFETY RELATED.

Nov 17, 2020

ELECTRICAL SYSTEM

2 complaints

The contact's son owns a 2020 Chevrolet Corvette. The contact stated that while her son was driving 65 MPH, the oil temperature and check engine warning lights illuminated; however, the driver was able to safely drive to the destination. Upon leaving and attempting to start the vehicle, the vehicle failed to start. The vehicle was towed to the dealer, who diagnosed a failure with the main wiring harness. The vehicle was not repaired. The contact was informed that the replacement part was on a national backorder. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 40,000.

Sep 03, 2025

Rear back up camera becomes unresponsive randomly, causing it to become unsafe when backing up

Jul 03, 2025

UNKNOWN OR OTHER

2 complaints

Periodically the Instrument Cluster(Speed, Tach and other gauges) goes black. When this happens you have know knowledge of any information about the vehicle speed, etc.. This lasts a variety length of times, but no longer that about 1minute. The instrument cluster then reappears, but usually will go out again in a few minutes. A message appears, "Service Instrument Cluster'" This will happens 4 or 5 times in a period of around 10 minutes then it will never happen again the rest of the current drive. This may not happen again for a couple of months of driving then it does it again.

Jan 20, 2025

THE FRONT TRUNK LID (THE LID) OPENED AT A SPEED OF ABOUT 40MPH ON A CITY STREET. THE WARNING LIGHT WAS NOT LITE PRIOR TO THIS INCIDENT AND NOTHING ACTIVATED THE LID DOOR SWITCH. THIS INCIDENT BENT THE LID HINGES AND DIS-ALIGNED THE LID RESULTING IN THE DAMAGING OF THE CORNERS OF THE QUARTER PANELS. I HAVE NOW TAPED DOWN THE LID IN FRONT TO PREVENT THIS OCCURRING AGAIN. I HAVE NOTIFIED MY CHEVY DEALER OF THIS INCIDENT AND WILL BE REPLACING THE HINGES AND REPAIR THE QUARTER PANELS.

Jul 17, 2020

STRUCTURE,VISIBILITY/WIPER

2 complaints

I JUST GOT MY 2020 CORVETTE DELIVERED LAST WEEK. I AM THE FIRST OWNER OF THE CAR AND TODAY I WAS DRIVING UP PCH TOWARDS MALIBU. WENT UP TO 80-90 MPH AT TIMES. DROVE FOR ABOUT 100 MILES. I STOPPED TO GET SOMETHING TO EAT. GOT BACK IN MY CAR AND PROCEEDED UP THE CANYONS FOR SOME SPIRITED DRIVING. THE CAR IS ALREADY BROKEN IN AT 1300 MILES. I DECIDED TO PULL OFF THE ROAD TO TAKE SOME PICTURES OF THE CAR. I PUT THE CAR IN PARK WITH THE PARKING BRAKE ON AND LEFT THE ENGINE RUNNING WITH THE KEY FOB IN THE CUPHOLDER. AFTER I GOT THE SHOTS I WANTED, I PROCEEDED TO DRIVE DOWN THE CANYON AND WITHIN 15 SECONDS I HEARD THE FRONT HOOD LATCH CLICK/THUMP (SAME SOUND YOU HEAR WHEN YOU PRESS THE BUTTON TO POP THE HOOD) RIGHT BEFORE I SAW THE HOOD FLY UP AND HEARD A SNAP. SUDDEN LOSS OF VISIBILITY ALMOST CAUSED MY CAR TO GO OFF THE CLIFF AS I COULDN'T SEE THE TURN. LUCKILY I WAS ABLE TO STOP THE CAR BEFORE GOING OFF THE ROAD. THE HOOD DID NOT HIT MY FRONT WINDSHIELD, BUT THERE IS SEVERE HINGE DAMAGE AS WELL AS DAMAGE TO BOTH FENDERS AND THE FRONT HOOD. I HAD MY WINDOWS DOWN AND MY ROOF OFF, DID NOT HAVE THE RADIO ON AND IT WAS QUIET ROAD. THERE WERE NO WARNING LIGHTS THAT THE HOOD LATCH WAS OPEN/DISENGAGED. EVEN WHEN THE HOOD FLEW UP, THERE WAS NO INDICATOR LIGHT OR BEEPING. I PUT THE HOOD BACK DOWN AS CAREFULLY AS I COULD.I HAD NO CHOICE BUT TO TRY MY BEST TO CLOSE THE HOOD SINCE I WAS IN AN AREA WITH NO RECEPTION IN ORDER TO KEEP DRIVING. IN THE CLOSED POSITION, THE HOOD IS NOW ABOUT 3/4 TO 1 INCH LOWER THAN EACH FENDER. SUPER PARANOID I TRIED TO DRIVE AS SLOWLY AS I CAN HOME, BUT I DID REACH SPEED UP TO 55 MPH. THANKFULLY IT DID NOT HAPPEN AGAIN. GM SPOKESPERSON BLAMES IT ON USER ERROR. I GUARANTEE YOU GUYS THIS IS NOT USER ERROR

Aug 03, 2020

WHILE DRIVING AT A PRUDENT SPEED THE HOOD OF MY VEHICLE OPENED WITH SOME DAMAGE TO THE HOOD(SPRUNG HINGES) AND BODY DAMAGE. I GOT A SIGNAL THAT THE HOOD WAS OPEN AND THEN THE HOOD SPRUNG OPEN. I WAS DRIVING AT 35-40 MPH AT THE TIME AND CAME TO A STOP IN A PRUDENT MANNER.(NO VISIBILITY)

Jul 12, 2020

SUSPENSION,POWER TRAIN,WHEELS

1 complaint

I replaced the battery in my C8 Corvette after three years of ownership. Upon removing the plastic cover from the frunk to access the battery, I discovered the two front strut mounts. To my dismay, I noticed excessive corrosion on both strut mounts, with the left side near an AC compressor line being considerably worse. I immediately took the car to the dealership, where they took pictures and agreed it was a design defect. They submitted a warranty claim to GM, which was denied multiple times. Despite having purchased an extended warranty when I bought the car, which still shows corrosion coverage until 2026 and over 100,000 miles, both the dealership and GM refused to repair my car. I explained that if my garage-kept car, which was never driven in the rain, had such severe corrosion at only 13,703 miles, one could only imagine the condition of a daily driver with the same defect. I then began noticing videos on YouTube exposing the problem and selling aftermarket strut covers (not OEM or from a dealership). This issue poses a significant safety hazard, as a strut could eventually fail due to corrosion. At high speeds of 70 mph on the interstate, this failure could potentially endanger the driver, passengers, and other motorists. However, the dealership and GM Customer Service continue to insist that it is a maintenance issue, despite it clearly being a design flaw. I voiced my concerns about the safety implications, but they offered no explanation or comment other than reiterating that it's a maintenance issue. I warned them that when someone dies as a result of this problem, they will eventually have to pay for the strut mounts and face additional lawsuits. They informed me that the conversation was being recorded, and I hope someone with authority will listen to it. It's not a matter of if, but when these strut mounts fail, endangering the safety and lives of others on the road. respectfully [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Feb 20, 2025

SUSPENSION

1 complaint

2020 CHEVROLET CORVETTE STINGRAY. CONSUMER WRITES IN REGARD TO RUSTING SHOCK TOWER HOUSING.

Mar 14, 2023

ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

THERE IS A STRONG SMELL OF GASOLINE IN THE TRUNK. THE SMELL IS STRONGER WHEN THE GAS TANK IS RECENTLY FILLED OR FULL.

Dec 30, 2020

VISIBILITY/WIPER

1 complaint

THE 2020 CHEVROLET CORVETTE COUPE WITH THE 1LT TRIM PACKAGE DOES NOT COMPLY WITH THE 20 DEGREE MINIMUM HORIZONTAL FIELD OF VIEW REQUIREMENT AS OUTLINED IN US DOT TP-111V-01. THE INTERIOR REAR VIEW MIRROR IS ESSENTIALLY USELESS GIVEN THE SMALL SIZE OF THE REAR HATCH GLASS. PLEASE NOTE THAT THE 1LT TRIM PACKAGE DOES NOT INCLUDE THE CAMERA AUGMENTED REAR VIEW MIRROR FOUND IN THE 2LT AND 3LT TRIM PACKAGES.

Sep 17, 2020

EXTERIOR LIGHTING

1 complaint

THE FRONT DRIVER SIDE DAYTIME DRIVING LIGHT WHICH IS ALSO THE TURN SIGNAL DOES NOT WORK. IT HASN'T WORKED FOR ALMOST 3 MONTHS AND CHEVY DOES NOT STOCK ANY HEADLIGHTS FOR THIS CAR. THIS HAS BEEN GOING ON FOR WAY TOO LONG AND I DON'T THINK THAT THEIR STATEMENT SEEMS ACCURATE ABOUT DRIVING WITHOUT THE LIGHT/TURN SIGNAL. EVEN THOUGH GM STATES IT OK TO DRIVE I FEEL IT'S NOT THAT SAFE AND HAVE NOT DRIVEN IT MUCH THESE PAST 3 MONTHS. THIS IS A NEW MODEL AND I KNOW IT'S DIFFICULT TO HAVE ALL PARTS AVAILABLE FOR A NEW CAR BUT A HEADLIGHT SHOULD BE SOMETHING THAT IS IN STOCK IN THEIR WAREHOUSE PRIOR TO SHIPPING THESE CARS TO THE PUBLIC.

Sep 09, 2020

⭐

4.5/5.0

32 reviews

Frequently Asked Questions

How many problems does the 2020 CHEVROLET Corvette have?

The 2020 CHEVROLET Corvette currently has 28 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2020 CHEVROLET Corvette?

The most common problems reported for the 2020 CHEVROLET Corvette are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2020 CHEVROLET Corvette problem data come from?

All problem and complaint data for the 2020 CHEVROLET Corvette comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.