How many problems does the 2002 CHEVROLET Express have?

The 2002 CHEVROLET Express currently has 82 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2002 CHEVROLET Express?

The most common problems reported for the 2002 CHEVROLET Express are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2002 CHEVROLET Express problem data come from?

All problem and complaint data for the 2002 CHEVROLET Express comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.

2002 CHEVROLET Express Problems

ENGINE AND ENGINE COOLING

9 complaints

TL*THE CONTACT OWNS A 2002 CHEVROLET EXPRESS 1500. WHILE DRIVING APPROXIMATELY 25 MPH, THE CONTACT NOTICED THAT THE VEHICLE WAS LEAKING ANTIFREEZE. THE VEHICLE WAS INSPECTED BY BOTH AN AUTHORIZED DEALER AND AN INDEPENDENT MECHANIC WHO STATED THAT THE FAILURE WAS A PLASTIC INTAKE GASKET LEAK. THE VEHICLE HAD NOT BEEN REPAIRED AND THE CONTACT HAD NOT CALLED THE MANUFACTURER. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000. THE CURRENT MILEAGE WAS APPROXIMATELY 60,000.

Apr 08, 2010

TL*THE CONTACT OWNS A 2002 CHEVROLET EXPRESS 1500. IN BETWEEN OIL CHANGES, THE CONTACT NOTICED A LEAK IN THE BACK OF THE INTAKE MANIFOLD. AS A RESULT, HE HAS TO CONSTANTLY ADD ANTIFREEZE TO THE VEHICLE. THE CONTACT SCHEDULED AN APPOINTMENT WITH THE DEALER. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 44,400 AND FAILURE MILEAGE WAS 28,000.

Nov 01, 2007

TL*THE CONTACT OWNS A 2002 CHEVROLET EXPRESS. WHILE DRIVING 50 MPH, THE VEHICLE COMPLETELY SHUT OFF AND WOULD NOT RESTART. THE VEHICLE WAS TOWED TO THE DEALER AND THEY REPLACED THE FUEL FILTER, HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS THEN TOWED TO A GM DEALER, WHO REPLACED THE CRANK SENSOR. THE CONTACT STATED THAT THE VEHICLE IS CURRENTLY OPERATING NORMALLY. THE CURRENT MILEAGE WAS 16,612 AND FAILURE MILEAGE WAS 16,594.

Oct 03, 2007

INTAKE MANIFOLD GASKET FAILURE CAUSING ENGINE TO SEIZE AT 69,700 MILES. *TR

Aug 23, 2007

2002 EXPRESS 3500 6.5 DIESEL VAN HAS STARTED INTERMITTENT STALLING AT HIGHWAY SPEEDS 60 MPH MID 09/2006. NO TROUBLE CODES LOCKED IN MEMORY. TWO CHEVY DLRS AND GM CUSTOMER SERVICE MADE AWARE OF PMD HEAT PROBLEM, BUT ALL THREE SOURCES CLAIM CAN'T REPAIR UNTIL MAJOR FAILURE. WHEN ENGINE STALLS AT SPEED, YOU LOOSE ALL POWER STEERING AND BRAKES. *NM

Nov 06, 2006

+ 4 more complaints for this component

TIRES

8 complaints

TIRES HAD MORE THAN 50% TREAD LEFT. RIGHT FRONT TIRE SUDDENLY STARTED SHAKING THE VEHICLE. DETERMINED BELT HAD BROKE. TIRE DEALER ALSO SAID OTHER FRONT TIRE WAS GOING BAD. A FEW MILES LATER ON A BUSY HIGHWAY READ TIRE SPLIT OPEN . PERFORMANCE TIRE OF TOPEKA AND COOPER TIRE COMPANY WOULD NOT MAKE ANY ADJUSTMENT FOR AN OBVIOUS DEFECT. (3 OUT OF 4 TIRES BREAKING WITHIN A WEEK). *TR

Jun 24, 2014

TL*THE CONTACT OWNS A 2002 CHEVROLET EXPRESS 1500. THE VEHICLE HAS COOPER COBRA RADIAL TIRES, SIZE P255\70R15 (NA). WHILE DRIVING APPROXIMATELY 70 MPH, THE TIRE TREAD SEPARATED WITHOUT WARNING ON THE REAR DRIVER'S SIDE OF THE VEHICLE. THE CONTACT PULLED TO THE SIDE OF THE ROAD AND CALLED ROADSIDE ASSISTANCE. THE TIRE WAS CHANGED AND THE CONTACT CONTINUED TO HIS DESTINATION. THE FAILURE RECURRED ON THE REAR PASSENGER SIDE OF THE VEHICLE. AN INDEPENDENT TIRE COMPANY REPLACED THE TIRE. THE CONTACT NOTICED THAT THE AIR PRESSURE IN THE FRONT PASSENGER SIDE TIRE WAS CONTINUOUSLY LOW. THE FAILURE MILEAGE, VIN, AND DOT NUMBER WERE UNKNOWN.

Oct 01, 2008

DT:THE CONTACT STATED THE LEFT REAR TIRE DEVELOPED A BULGE WITHIN THE TREAD. HE BROUGHT THE VEHICLE TO AN INDEPENDENT REPAIR SHOP, AND THEY REPLACED THE TIRE WITH A SPARE. WHEN HE RETURNED HOME THE VEHICLE WAS TAKEN TO A FIRESTONE DEALER, WHO DISCOVERED THERE WAS A COMPLETE BELT SEPARATION ON THAT TIRE. A SECOND INCIDENT LATER OCCURRED ON THE LEFT FRONT TIRE IN A SIMILAR FASHION. BOTH OF THE FAILED FIRESTONE TIRES WERE REPLACED WITH GOODYEAR TIRES. WHILE DRIVING THE RIGHT REAR REMAINING FIRESTONE TIRE BLEW OUT AT 75 MPH RESULTING IN DAMAGE TO THE VEHICLES FENDER AND BUMPER AREA. HE AVOIDED ANY COLLISION. HE TOOK PHOTOGRAPHS OF THE EXTENSIVE DAMAGE. NO FURTHER REPAIRS OR CORRECTIONS HAVE BEEN MADE AT THIS TIME. THIS IS A FIRESTONE STEELTEX R4S LT245/75/R16 LOAD RANGE E. THESE WERE THE ORIGINAL TIRES ON THE VEHICLE AT PURCHASE. *AK UPDATE 12/27/2005 - THE TIRES WERE MADE IN CANADA. *NM

Nov 02, 2005

DT: 2002 CHEVROLET EXPRESS. THE CONTACT STATED THE SPARE TIRE IS SECURED BY STRAPS ,AND ONE OF THE STRAPS CAME OFF THE VEHICLE. THERE WAS NO ONE BEHIND THE CONTACT'S VEHICLE. THEREFORE, NO ONE WAS INJURED. THE SPARE TIRE HAD BEEN USED A YEAR AGO. THE MANUFACTURER STATED THIS HAPPENED REGULARLY. ALSO, THE TIRE CAME OFF AT THIS TIME AND THAT TIRE WAS LOST. THE CONTACT PURCHASED ANOTHER TIRE. IT WAS LOCATED IN THE BACK OF THE VEHICLE. *AK

Oct 12, 2005

WHILE DRIVING AT 65 MPH REAR DRIVER'S SIDE TIRE BLEW OUT WITH WARNING. CONSUMER EXAMINED THE TIRE, AND DISCOVERED THAT THE TIRE BLEW OUT AT THE SIDEWALL.*AK

Mar 08, 2004

+ 3 more complaints for this component

ELECTRICAL SYSTEM

7 complaints

I HAVE A 02'CHEVY IMPALA WHEN I TURN IT ON ALL ELECTRIC COMES ON AND THE ENGINE RUNS FOR A SPLIT SECOND AND DIES THEN THE BATTERY LIGHT AND SERVICE TRACTION SYSTEM COMES ON I GOT THE FUEL PUMP AND SENSOR REPLACED STILL THE SAME PROBLEM OCCURS. I WAS ABLE TO DRIVE IT FOR A FEW MILES AFTER READING THE MANUAL AND PUSHING THE GAS TO THE FLOOR WHILE HOLDING THE KEYS ON FOR THREE SECONDS BUT EVENTUALLY IT DIED AGAIN. PLEASE HELP!!!!! *TR

Sep 05, 2010

THIS IS A GENERAL POINT OF INFORMATION MESSAGE: FOR THE LAST DECADE OR MORE, GM VEHICLES HAVE A PROPENSITY TO BURN OUT THEIR LAMPS DUE TO AN OVERCHARGE CONDITION (CAUSE UNKNOWN TO ME); THIS CONDITION CAN AFFECT ANY OF THE LAMPS OR BULBS, MOST NOTICABLY HEADLAMPS, TAIL LIGHTS, AND RUNNING (PARKING) LAMPS. COULD YOU PLEASE INVESTIGATE THIS ELECTRICAL DEFECT IN ALL GM VEHICLES.*TR

May 20, 2010

THE VEHICLE SHUTS DOWN WITHOUT WARNING WHILE DRIVING, FOUND A GM SERVICE BULLETIN STATING TO REPLACE THE DISTRIBUTOR CAP AND ROTOR BUT HAVE DONE THAT NOW 4 FOUR TIMES BUT THIS DOESN'T CORRECT THE CAUSE JUST THE EFFECT. TO DATE IT HAS REDENDERED OUR VEHICLE UNDRIVEIBLE DUE TO IT'S UNRELIBILITY. GM ISN'T DOING ANYTHING TO HELP US OUR OUR WHEELCHAIR BOUND SON WHO RELIES ON THIS VEHICLE FOR MEDICAL APPOINTMENTS.

May 08, 2005

VAN IS USED IN A MUNICIPAL PARKS AND RECREATION DEPARTMENT FOR MAINTENANCE DUTIES. OPERATOR STARTED VEHICLE AT BEGINNING OF DAY TO WARM UP. OPERATOR LEFT THE VEHICLE. OPERATOR RETURNED APPROXIMATELY FIVE MINUTES LATER AND SAW SMOKE COMING FROM INSIDE THE PASSENGER AREA. OPERATOR CALLED 911 AND RETRIEVED A DRY POWDER EXTINGUISHER. OPERATOR SAW FLAMES COMING FROM AN AREA IN THE REAR OF THE DRIVER'S SEAT. OPERATOR TURNED OFF IGNITION AND USED EXTINGUISHER ON THE FIRE, PUTTING IT OUT. INVESTIGATION SHOWS AREA OF ORIGIN TO INSIDE THE DRIVER?S SIDE SEAT BELT CHANNEL. PLASTIC MOLDING COVERS THIS CHANNEL. A WIRING HARNESS IS LOCATED IN THIS CHANNEL. HEAVIEST BURN OF THE HARNESS IS DIRECTLY AT THE CONNECTION OF THE HARNESS TO THE DRIVER?S SIDE SEAT BELT MECHANISM LOCATED AT THE FLOOR. FIRE PARTIALLY CONSUMED HARNESS AND PLASTIC MOLDING. THERE ARE PICTURES OF THE DAMAGE AND HARNESS. HARNESS WAS CUT BACK TO CLEAN WIRING ON BOTH SIDES OF DAMAGED SECTION AND IS AVAILABLE FOR INSPECTION.*AK

Apr 26, 2005

Fire: 1

VEHICLE WOULD NOT START. WENT INSIDE TO CALL TOW TRUCK TO HAVE IT TOWED TO MECHANIC. TURNED AROUND AND IT WAS ON FIRE. VEHICLE WAS NOT RUNNING;PARKED.

Feb 28, 2005

Fire: 1

+ 2 more complaints for this component

STRUCTURE

6 complaints

THE SIDE HINGES SEIZE UP AND BREAK. IT THROWS THE DOOR ALIGNMENT OFF AND I AM NO LONGER ABLE TO COMPLETELY CLOSE THE FRONT SIDE DOOR AND IT KEEPS THE PASSENGER DOOR FROM OPENING ALSO. THIS IS A CONTINUEING PROBLEM CHEVROLET HAS WITH THEIR EXPRESS VANS. IT IS A DESIGN PROBLEM AND ALSO CHEAP MATERIALS CAUSED IT TO RUST AND SEIZE UP AND THEN BREAK THE HINGE, THE HINGE IS WELDED ON. VERY EXPENSIVE TO HAVE REPARED. IT IS DANGEROUS AS PEOPLE CAN NOT GET OUT OF THE VAN. CHEVROLET NEEDS TO OFFER AN INEXPENSIVE FIX FOR THIS.

Aug 05, 2018

ONE OF THE HINGES TO THE DOUBLE SIDE DOORS ON THE FULL SIZE 2002 CHEVROLET EXPRESS BROKE OFF TODAY. *AK

Jun 11, 2007

FRONT DOORS DO NOT CLOSE TIGHTLY. SEVERE ROAD/WIND NOISE AT NORMAL HIGHWAY SPEEDS. NOISE WORSENED ON OUTSIDE DOOR WHEN TURNING (TURN TO RIGHT - LEFT DOOR NOISE INCREASES). I AM CONCERNED ABOUT THE INTEGRITY OF THE DOOR ATTACHMENT MECHANISM. PROBLEM EXISTED SINCE VEHICLE WAS NEW, BUT BECOMES MORE PRONOUNCED WITH TIME.*AK

Jan 11, 2005

RIGHT FRONT TIRE IS WEARING OFF ON OUTER EDGE OF TIRE. INSIDE DEPTH IS 8/32 OUTSIDE DEPTH IS 3/32, WITH ONLY APPROXIMATELY 8000 MILES ON TIRE. GOING ON THIRD SET OF TIRES WITH ONLY 17,000 ON IT. TOOK IT TO DEALER TWICE, DOES NOT KNOW WHAT IS WRONG WITH IT. 2002 EXPRESS COMMERCIAL CUTAWAY-12000 GVW. *AK

Mar 01, 2004

THE VEHICLE WAS NOT STABLE.*JB

Feb 11, 2003

+ 1 more complaint for this component

POWER TRAIN

6 complaints

I PURCHASED MY 2002 CHEVROLET IMPALA LS IN DECEMBER, 2004. GREAT LOOKING VEHICLE WITH NUMEROUS PROBLEMS. THE MOST RECENT AND SEVERE HAS COME OVER THE LAST FEW DAYS. WHILE ACCELERATING ON AN ENTRANCE RAMP, THE CAR WILL NOT SHIFT PROPERLY; VERY ROUGH AND THE RPM'S GO TO 4000 OR ABOVE BEFORE SHIFTING OR IF I LET OFF THE ACCELERATOR. I AM TERRIFIED THAT THE TRANSMISSION IS GOING TO COME OUT COMPLETELY WHILE DRIVING WITH MY FAMILY IN THE VEHICLE; I AM TAKING THE CAR TO A MECHANIC TO HAVE IT LOOKED AT. I HAVE ALSO BEEN RESEARCHING OTHER COMPLAINTS ABOUT THE CAR, AND TO MY HORROR, I AM EXPERIENCING MUCH OF THE SAME AS OTHER CONSUMERS. HOW CAN SO MANY COMPLAINTS BE ISSUED ABOUT THE SAME VEHICLE AND GENERAL MOTORS NOT FIXING THE PROBLEMS?? *TR

Nov 27, 2007

TWO WEEKS AGO OUR 4 YEAR OLD 1500 EXPRESS VAN, A CONVERSION VAN, DEVELOPED TRANSMISSION PROBLEMS. THE STICKER PRICE WAS OVER $55,000. THE MILEAGE IS 42,000 MILES. WHEN THE CHEVY DEALERSHIP TOLD ME THAT THE REPAIR COST WOULD BE OVER $3,000, IT PROMPTED ME TO CALL GM CUSTOMER SERVICE. THE RESULT WAS APPROXIMATELY $500 OFF OF THE TRANSMISSION REPAIR, OR A $1,000 BUY OUT TO BE APPLIED TO A PURCHASE OF A NEW GM VEHICLE. THE REASON WE DECIDED TO PURCHASE OUR SECOND CHEVY VAN WAS BECAUSE WE HAD VERY GOOD LUCK WITH OUR 1998 VAN. I USE THE WORD LUCKY INTENTIONALLY BECAUSE IT SEEMS THAT EITHER YOU ARE LUCKY TO HAVE A GM PRODUCT WORK SATISFACTORILY, OR YOU END UP WITH AN UNREASONABLE PROBLEM/COST. OUR CURRENT VAN HAS BEEN A BIG PROBLEM HAVING DIED ON COUNTRY ROADS AT 39,000 MILES. THE COST OF THAT REPAIR WAS OVER $600. TODAY, AS I MENTIONED, WE WERE LOOKING A REPAIR COST OF OVER $3,000. ALL PROBLEMS INCURRED WITH NORMAL USAGE (NO TOWING, ONLY LONG TRIPS, AND REGULAR 3000 MILE OIL CHANGES). *JB

Feb 18, 2007

RE 2002 CHEVY TAHOE TRANSMISSION PROBLEMS: UP UNTIL THE 34,000 MILE RANGE THE VEHICLE DID JUST THAT, RUN FLAWLESSLY. HOWEVER, AT 34,000 MILES (NOVEMBER OF 2004) THE TRANSMISSION WENT OUT. MY WIFE WAS DRIVING TO WORK AND NEEDED TO ACCELERATE TO MERGE ONTO THE FREEWAY AND INSTANTLY THE TRANSMISSION BEGAN TO WHINE AND STOPPED OPERATING WHICH PLACED HER INTO THE PATH OF A LARGE TRUCK BEARING DOWN ON HER RATHER QUICKLY. THANKFULLY SHE WAS ABLE TO GLIDE OUT OF THE PATH OF THE TRUCK TO THE SIDE OF THE ROAD. WE HAD THE TAHOE TOWED BACK TO OUR DEALERSHIP AND WE DETERMINED THAT THE TRANSMISSION "SUN SHELL" HAD FAILED AND WOULD BE REPLACED. OUR DEALER ASSURED US THAT THIS WOULD SOLVE THE PROBLEM, BECAUSE THE NEW PARTS WERE DESIGNED TO PREVENT THIS FROM OCCURRING IN THE FUTURE. OUR DEALER FURTHER STATED THAT THEY HAVE BEEN REPAIRING A LARGE NUMBER OF VEHICLES WITH THESE FAILURES. OUR TAHOE WENT OFF OF IT'S NEW CAR WARRANTY ON MILEAGE NOT NUMBER OF MONTHS SOMETIME IN APRIL OF 2005 (36 MONTHS WOULD HAVE ENDED THIS AUGUST). JUST THIS PAST MONDAY (SEPTEMBER 19, 2005) MY WIFE WAS AGAIN ON HER WAY TO WORK WHEN AGAIN THE TRANSMISSION FAILED IN OUR 2002 TAHOE. THE MILEAGE WAS APPROX: 41,000 ( TOTAL PERIOD OF MILES AND THE LENGTH OF TIME FROM THE PREVIOUS FAILURE WAS APPROX: 7 MONTHS). THE CIRCUMSTANCES WERE THE SAME, SHE WAS ACCELERATING TO MERGE ONTO THE FREEWAY AND AGAIN THE TRANSMISSION BEGAN TO WHINE AND SLIP. THIS TIME SHE WAS ABLE TO CONTINUE DRIVING TO THE SIDE OF THE ROAD AND RELATIVE SAFETY. WE HAD THE VEHICLE TOWED BACK TO OUR DEALERSHIP AND AGAIN THE DEALER ADVISED THAT THE "SUN SHELL" HAD FAILED. I WENT TO PICK UP THE CAR ON FRIDAY SEPTEMBER 23, 2005 AND WHILE I WAS AT THE DEALERSHIP THE MECHANIC SHOWED ME THE DAMAGED PART AND A BENCH THAT CONTAINED SEVERAL DAMAGED "SUN SHELL". IT OBVIOUSLY DOES NOT TAKE MUCH EFFORT TO REALIZE THAT THERE IS A DESIGN FLAW WITH THIS PARTICULAR TRANSMISSION AND SPECIFICALLY THIS PART. *JB

Sep 28, 2005

2002 CHEVY VAN/6.5 DIESEL LEAKS OIL FROM REAR AXLE SEALS. *LA

Apr 06, 2004

THE VEHICLE'S TRANSMISSION HAS FAILED WITHOUT WARNING WHILE BACKING OUT OF THE DRIVEWAY. AS A RESULT THE VEHICLE COASTED SLOWLY INTO THE MIDDLE OF THE STREET. THE CAUSE HAS YET TO BE DETERMINED. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM

Mar 25, 2004

+ 1 more complaint for this component

SERVICE BRAKES, HYDRAULIC

6 complaints

BRAKES ON MY 2002 CHEVY EXPRESS VAN ARE NOT LARGE ENOUGH TO STOP VEHICLE WITHOUT WARPING ROTORS. THIS IN TURN CAUSES LONGER STOPPING DISTANCES AND A VIBRATION THAT CAUSES STEERING WHEEL TO PULSATE. *NM

Jan 15, 2007

DT*: THE CONTACT STATED WHILE APPLYING BRAKE PRESSURE AT VARIOUS SPEEDS, THERE WAS A THUMPING NOISE FROM THE UNDERHOOD AREA FOLLOWED BY ABS ACTIVATION. THE CONTACT INSPECTED UNDERNEATH THE VEHICLE AND DETERMINED BRAKE FLUID WAS LEAKING FROM A BRAKE LINE. THE VEHICLE IS SCHEDULED FOR FURTHER INSPECTION AT THE DEALER.

Apr 12, 2006

BRAKES WERE MAKING A "GRUMBLING NOISE". NOT THE TYPICAL SQUEAL OR GRINDING NOISE ASSOCIATED WITH BRAKES. WENT TO THE DEALER AND HE SAID THE FRONT DISC BRAKES WERE BADLY WORN. ONLY 32,000 MILES ON THE VEHICLE. NEVER, NEVER HAVE I EVER HAD TO REPLACE BRAKES WITH SUCH LOW MILEAGE. DRIVING FOR 45 YEARS AND NEVER HAD THIS HAPPEN. THEY FIXED IT, NOT UNDER WARRANTY, SO I PAID. NOW, WITH A YEAR ON THE NEW BRAKE LININGS, THEY ARE MAKING NOISE AGAIN. VERY DISTURBING. THE VEHICLE IS USED FOR WORK AND IS NOT ABUSED, I AM THE ONLY ONE THAT DRIVES IT. DRIVING VANS FOR 30 YEARS AND THIS IS VERY DISAPPOINTING. *JB

Mar 25, 2006

SINCE THE 2002 CHEVROLET 1/2 TON CUSTOM VAN WAS PURCHASED IT HAS GIVEN ME BRAKE PROBLEMS. FIRST WAS THE ROTORS WHICH WAS SETTLED IN COURT, GENERAL MOTORS CUSTOMER SATISFACTION PROGRAM! THE BRAKES HAVE FAILED ABOUT 4 TIMES, 3 TIMES WITH ME AND ONCE WITH MY SON. THE STEERING ALSO GOES HARD. THE VAN WAS TAKEN TO THE CHEVROLET DEALERSHIP TO BE REPAIRED. THEY CLAIMED NOTHING WAS WRONG AND TO TAKE IT BACK. MY HUSBAND POINTED OUT THE NHTSA OFFICE OF DEFECTS INVESTIGATION 05V005000 BUT THEY COULD CARE LESS AND CLAIMED THEY LACK THE SKILL TO WORK ON BRAKE PROBLEMS. *NM

Sep 29, 2005

DC: HIS BRAKES DO NOT WORK CORRECTLY. WHEN YOU STOP THE ABS SYSTEM KICKS IN, THE PEDAL JERKS BACK AND FORTH. THE VEHICLE DOES NOT WANT TO STOP CORRECTLY. *AK

May 06, 2005

+ 1 more complaint for this component

EXTERIOR LIGHTING

4 complaints

2002 MALIBU. TURN SIGNAL/HAZARD FLASHER FAILURE. *NM

Dec 13, 2006

REAR BRAKE LIGHTS DOES NOT LIGHT AT THE SAME TIME. THEY OPERATE LIKE A CAROUSEL. WHEN THE LIGHT SWITCH IS TURNED ON ONLY THE CENTER BRAKE LIGHT ILLUMINATES. *JB

Nov 11, 2006

1 AFTER 70000 MILES, THE GROUND CONNECTION IN THE BRAKE LIGHT/TAILLIGHT SOCKET BECOMES OXIDIZED FROM HEATING UP. 2. THE BRAKE LIGHTS QUIT WORKING. 3. I REMOVED A PLASTIC CLIP FROM THE BULB SOCKET AND ALLOWED THE GROUND WIRE TO ACQUIRE A NEW CONNECTION. 2002 CHEV EXPRESS VANPOOL VANS AT HILL AIR FORCE BASE, UTAH. *AK

Apr 08, 2005

DEALERSHIP DON'T HAVE THE PARTS TO PERFORM THE OWNER NOTIFICATION FOR THE RUNNING BOARD LIGHTS.*AK

Jun 02, 2003

STEERING

4 complaints

A VERY UNNERVING CONDITION IS PRESENT IN OUR 2002 TAHOE. THERE IS A LOOSE/ UNSTABLE FEELING IN THE STEERING WHEN TURNING. MY MECHANIC SAID WE HAVE A WARPED CENTER STEERING SHAFT AND HE CAN NOT REPAIR AS THE PART IS BACK ORDERED BY TENS OF THOUSANDS NATIONWIDE (INDICATING A UNIVERSAL PROBLEM WITH THIS VEHICLE) I HAVE BEEN EXPECTING A RECALL BUT HAVE NOT SEEN ONE. GM HAS NOT REPLIED TO MY INQUIRY.

Jun 06, 2005

THERE IS A KNOCKING IN THE STEERING. POOR STEERING CONTROL. DEALER REPLACED STEERING GEAR 3 TIMES AND THEN WAS TOLD BY GEN MOTORS NOT TO REPLACE IT AGAIN. THE PROBLEM STILL EXISTS. THE VEHICLE IS STILL IN WARRANTY. PRESENTLY AT A STANDOFF WITH GM. THEY WON'T FIX, I WON'T PAY.*AK

Apr 28, 2004

THE VEHICLE STEERING GEAR BOX FAILED. THE DEALER HAS REPLACED FOUR TIMES, HOWEVER PROBLEM STILL EXISTS. PLEASE PROVIDE ADDITIONAL INFORMATION. *PH

Dec 04, 2003

WHILE TRAVELING ON THE HIGHWAY STEERING COLUMN HAS A LOT OF PLAY INSIDE OF THE STEERING WHEEL. *AK

Jun 24, 2003

SUSPENSION

3 complaints

The contact owns a 2002 Chevrolet Express. The contact stated while driving 65 MPH, she heard an abnormal loud banging sound coming from the rear end of the vehicle. The contact stated that the passenger’s side rear axle detached from the vehicle, causing the tire to detach and roll away. The contact did not sustain any injury. The vehicle was towed to a tow lot. The dealer and the manufacturer were not notified. The vehicle was not diagnosed nor repaired. The approximate failure mileage was 100,000.

Sep 30, 2021

2002 CHEVROLET EXPRESS 3500. CONSUMER WRITES IN REGARDS TO BROKEN DRIVERS SIDE SPRING LEAF. *LD THE CONSUMER STATED AFTER A POTHOLE BROKE THE SPRING LEAVE, IT WAS DISCOVERED THAT SPRING LEAF WAS INCORRECTLY INSTALLED BY THE FACTORY. *JS

Feb 11, 2021

WHILE DRIVING AT ANY SPEED VEHICLE PULLED TO THE LEFT. DEALER STATED THEY HAVE REPAIRED THE VEHICLE. CONSUMER INSISTED THAT AS A RESULT OF THE REPAIRS WHEN APPLYING THE BRAKES VEHICLE PULLED TO THE LEFT EVEN MORE.*AK

Dec 07, 2004

ELECTRICAL SYSTEM,EXTERIOR LIGHTING

3 complaints

DT: 2002 CHEVROLET IMPALA LS. THE CONSUMER STATED CAR DEVELOPED A SPORADIC FAILURE OF TURN SIGNALS. THIS HAS BEEN HAPPENING FOR ABOUT 3 WEEKS. INVOLVED LEFT AND RIGHT TURN SIGNALS. THE CONSUMER CONTACTED CHEVROLET, THEY TOLD THE CONSUMER TO CONTACT THE DEALER, IMPERIAL CHEVROLET. HOWEVER, THE DEALER TOLD THE CONSUMER SHE WOULD HAVE TO PAY $46.00 JUST TO LOOK AT CAR. THE CONSUMER STATED THAT AN ARTICLE IN LOCAL NEWSPAPER STATED THERE HAS BEEN A TREND OF FAULTY IGNITION SWITCHES IN THIS MODEL VEHICLE. WHEN THE CONSUMER CALLED IMPERIAL CHEVROLET THEY STATED THEY WERE WELL AWARE OF THE PROBLEM WITH THE FAULTY IGNITION SWITCHES. *AK

Sep 26, 2005

CONSUMER NOTICED THAT WHEN HEADLIGHTS ARE TURNED ON TAIL LIGHTS FUSE BLOWS OUT INTERMITTENTLY.*AK

Aug 25, 2003

2002 CHEVROLET EXPRESS VAN WITH EXPLORER CONVERSION - BURST INTO FLAMES WHILE IN OUR DRIVEWAY (ENGINE OFF). EXTENSIVE FIRE DAMAGE TO DRIVERS SIDE. EXTENSIVE SMOKE DAMAGE TO INTERIOR. FIRE MARSHALL STATES SMOKE PATTERN INDICATED FIRE ORIGONATED A BOTTOM OF DRIVER'S DOOR - LIGHT OR WIRING. OF NOTE, A "RECALL NOTICE" ARRIVED AT OUR HOME IN THE MAIL FOR THE RUNNING BOARD LIGHT WIRING HARNESS ON 2/5/03 WHICH WAS "DATED" 1/23/03.

Feb 06, 2003

Fire: 1

SERVICE BRAKES

2 complaints

2 DAYS AGO I WAS DRIVING ON THE BALTIMORE BELTWAY TRAFFIC MADE AN ABRUPT STOP I HIT MY BRAKES AND THE PEDAL WENT TO THE FLOOR LUCKILY I WAS IN THE RIGHT LANE AND COULD USE MY PARKING BRAKE AND DOWNSHIFTING TO GET OFF THE ROAD. I WAS ABLE TO GET OFF THE NEXT EXIT AND TAKE BACK ROADS HOME USING MY PARKING BRAKE TO STOP. *TR

Nov 29, 2016

BRAKES FAILED WITH NO WARNING. UPON INSPECTION IT WAS DETERMINED THAT BRAKE LINES BURST DUE TO RUSTING.

Sep 18, 2013

VISIBILITY

2 complaints

DRIVER'S SIDE REAR VIEW MIRROR VIBRATES EXCESSIVELY. HARD TO VIEW ITEMS ON THE MIRROR. *TR

Apr 18, 2009

DRIVERS SIDE REAR VIEW MIRROR VIBRATES AT HIGHWAY SPEEDS. I HAVE LEARNED TO LIVE WITH IT BUT I'VE HAD THE PROBLEM SINCE LATE 2002, WHEN THE CAR WAS LESS THAN A YEAR OLD. *TR

May 13, 2008

FUEL SYSTEM, GASOLINE

2 complaints

DT: THE CONTACT STATED WHILE DRIVING THE VEHICLE STALLED INTERMITTENTLY. THE VEHICLE STALLED WHEN SLOWING DOWN OR WHEN STOPPING. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND THE FUEL INJECTOR PUMP WAS REPLACED, THIS REPAIRED THE VEHICLE.*AK UPDATED 12/07/05. *JB UPDATED 12/7/2005. *NM

Nov 16, 2005

WHILE TRAVELING ON HIGHWAY VEHICLE SHUT OFF, AND GASOLINE HAD LEAKED ALL OVER THE ROAD. FIRE DEPARTMENT WAS CALLED OUT. *AK

Jun 17, 2002

AIR BAGS

2 complaints

WHEN DRIVING AT AN UNDETERMINED SPEED AIRBAG WARNING LIGHT APPEARED ON THE DASHBOARD. CONSUMER WILL TAKE THE VEHICLE TO THE DEALERSHIP FOR INSPECTION. *AK THE CONSUMER WAS TOLD THAT WATER CAUSED THE AIR BAG SENSOR TO FAIL. *NM

Jun 25, 2004

VEHICLE WAS IN A FRONTAL COLLISION, BUT NONE OF THE AIR DEPLOYED UPON IMPACT. DRIVER SUSTAIN SERIOUS BODILY INJURIES. PLEASE PROVIDE MORE DETAILS. PLEASE PUT THE CORRECT MODEL. PH

Feb 07, 2003

Crash: 1

Injuries: 1

SEAT BELTS

1 complaint

REAR SEAT BELTS FAIL TO LOCK MY VEHICLE IS A CONVERSION VAN BUILT BY DEBUT IN SAGINAW MICHIGAN. RECENTLY MY GRANDCHILDREN NOTICED THAT THE REAR SEAT BELTS FAILED TO LOCK. THOSE BELTS ARE ON THE SEAT/BED UNIT. THE SEAT BELTS HAVE THE NAME ATWOOD MOBILE PRODUCTS ON THEM. I INSPECTED THE SEAT BELTS AND DETERMINED THAT THE PLASTIC COATING ON THE MALE END OF THE BELT PREVENTED THE MECHANISM FROM PROPERLY LOCKING IN PLACE. I CUT ENOUGH OF THE PLASTIC COATING OFF TO ALLOW THE ENDS TO PROPERLY LOCK IN PLACE. THEY WORK FINE NOW. MY CONCERN IS THAT THERE MAY BE MANY MORE VANS WITH SEAT BELTS THAT DO NOT PROPERLY LOCK IN PLACE.

Aug 19, 2015

STRUCTURE,UNKNOWN OR OTHER,VISIBILITY/WIPER

1 complaint

WHEN I CAME OUTSIDE THE GLASS WAS BROKEN AND HAD BEEN THROWN TO THE OUTSIDE OF THE VEHICLE. THE VEHICLE HAD BEEN DRIVEN THE DAY BEFORE AND WAS FINE. IT WAS PARKED IN THE SHADE AND AWAY FROM ANYTHING WHICH COULD HAVE HIT IT. IT WAS LOCKED AND NOT TOUCHED IN ANY WAY. THE BROKEN FRAGMENTS WERE ON THE GROUND BELOW THE GLASS FRAME AREA. IT IS THE SAME TYPE OF GLASS THAT I SAW IN THE STORY ON THE NEWS YESTERDAY ABOUT THE SUN ROOFS THAT BREAK. WHEN I SAW THE STORY I KNEW THIS HAD TO BE THE EXPLANATION. I HAVE A PICTURE AND THE TEXT I SENT THAT DAY BECAUSE I WAS SO SHOCKED AT HOW SOMETHING LIKE THIS COULD HAPPEN, IT MADE NO SENSE. NOW IT MAKES PERFECT SENSE.

Aug 08, 2015

UNKNOWN OR OTHER

1 complaint

PASSLOCK SECURITY SYSTEM CONSTANTLY WON'T ALLOW VAN TO START. CHEVROLET SAYS TO HAVE THE SYSTEM "RELEARN THE KEY" BY WAITING FOR 10 MIN THEN TRYING TO START THE VEHICLE. IT SOMETIMES TAKES 3-4 TRIES OF DOING THIS BEFORE IT STARTS.

Aug 30, 2013

ENGINE

1 complaint

TL* THE CONTACT OWNS A 2002 CHEVROLET EXPRESS CUTAWAY G3500. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO COAST ONTO THE SHOULDER AND RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE A DIAGNOSTIC WAS PERFORMED AND LOCATED THE FAILURE AT THE CRANK SHAFT POSITION SENSOR. THE LOCAL MECHANIC REPLACED THE CRANK SHAFT POSITION SENSOR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 69,196 AND THE APPROXIMATE CURRENT MILEAGE WAS 71,000.

Aug 24, 2012

STEERING,SERVICE BRAKES, HYDRAULIC

1 complaint

2002 CHEVY 2500 EXPRESS VAN. FAILURE OF POWER BOOSTER, LOST BOTH BRAKE POWER AS WELL AS STEERING POWER. ALMOST IMPOSSIBLE TO CONTROL CAR. REPLACED ONCE, FAILED AGAIN 6 MONTHS LATER. REPLACED AGAIN. FAILED AGAIN THIS YEAR. I AM NOW ON MY FORTH POWER BOOSTER, FAILURE IS VERY DANGEROUS AS YOU LOSE BOTH STEERING AND BRAKES AT SAME TIME. *TR

Feb 23, 2010

LATCHES/LOCKS/LINKAGES

1 complaint

SIDE DOOR DOES NOT CLOSE WELL UNLESS DOOR IS SLAMMED. THIS IS BECAUSE IT SEEMS THAT THE WEIGHT OF THE DOOR HAS MADE THE DOOR LEAN DOWNWARD. *TR

May 13, 2008

SEATS

1 complaint

TL*THE CONTACT OWNS A 2002 CHEVROLET EXPRESS 1500. THE SEAT BRACKETS THAT HOLD THE SEAT TO THE TRACK CONSTANTLY BREAK, WHICH CAUSES THE SEAT TO BECOME OFF TRACK. THE SEAT HAS BEEN REPAIRED TWICE; HOWEVER, THE FAILURE PERSISTS. THE DEALER AND MANUFACTURER HAVE NOT OFFERED ANY ASSISTANCE. THE FAILURE MILEAGE WAS 26,000 AND CURRENT MILEAGE WAS 37,474. UPDATED 02-19-08 *BF

Jan 22, 2008

PARKING BRAKE

1 complaint

THE 2002 CHEVROLET TAHOE HAS FAILED INSPECTION BECAUSE OF THE EMERGENCY BRAKE.. IT WAS COMPLETELY USELESS. IT DIDN'T WORK. WHY I DON'T KNOW, BUT THE INSPECTION PLACE STATED THAT THEY HAD FAILED NUMEROUS TAHOES WITH THE SAME PROBLEM. I FELT THAT IT WAS UNSAFE AND CHEVROLET SHOULD RECALL THE FEW THAT HAVE THIS PROBLEM. WHY DID IT HAVE TO BE AN INNOCENT PARTY CONCERNING SEVERAL DEATHS OR THOUSANDS OF PEOPLE REPORTING IT BEFORE IT IS RECALLED. I DIDN''T EVEN USE THE BRAKE HOW COULD IT NOT WORK ANYMORE.

Jun 24, 2007

SERVICE BRAKES, HYDRAULIC,POWER TRAIN

1 complaint

THE REAR END WENT OUT AND THE ROTORS ARE WARPED. I HAD THE REAR END REPLACED AND THE SERVICE TECH SAID HE HAD NEVER SEEN ANYTHING LIKE THIS IN HIS HISTORY OF WORKING ON VEHICLES. I HAD JUST PURCHASED THE VAN JAN. 28TH AND IT HAD A 60 DAY WARRANTY. I HAD TAKEN IT BACK TO THE DEALERSHIP ON FEB 17TH AND REPORT THE NOISES IT WAS MAKING AND THEY IN TURN SAID NOTHING WAS WRONG. THE SERVICE TECH THAT REPLACED THE REAR END SAID IT COULD NOT HAVE BEEN MISSED BECAUSE THE DIFFERENTIAL WAS BENT COMPLETELY UP ON THE AXLES. HE SAID IT WAS DUE TO EITHER WHOEVER OWNED IT PREVIOUS HAD TOWED SOMETHING TO HEAVY OR THE THERE WAS A MANUFACTURER DEFECT IN THE DIFFERENTIAL. REGARDLESS HE DEALERSHIP (LAWRENCE MARSHALL) IN DENISON TX WILL NOT STAND BEHIND IT AND I AM OUT OF POCKET FOR THIS BIG EXPENSE. THEY OVER CHARGED ME FOR THE VEHICLE AND NOW THIS. I HAVE A BIG CONCERN BECAUSE THE NOISE IT WAS MAKING HAD STOPPED AFTER THE REAR END WAS REPLACED, BUT WHEN I WAS DRIVING IT TODAY IT CLUNKED TWO DIFFERENT TIMES, SAME NOISE AS BEFORE, SO NOW I AM WORRIED. I DON'T KNOW WHO TO TRUST TO HELP ME AS I HAVE BEEN RIPPED OFF SO BAD NOW. CAN YOU PLEASE HELP ME OR ADVISE ME WHERE I CAN HAVE THIS VEHICLE COMPLETELY CHECKED OUT. THE SERVICE TECH SAID IT WAS A MIRACLE THAT THE DRIVE SHAFT DID NOT FALL OUT ON THE TRIP MYSELF AND GRANDCHILDREN WERE ON. IT BROKE DOWN IN OHIO AND I LIVE IN OKLAHOMA SO OF COURSE IT SET ME BACK A LOT OF EXPENSE I COULD NOT AFFORD. I THOUGHT THE DEALERSHIP SHOULD STAND BEHIND THE 60 DAY WARRANTY SINCE I HAD TAKEN IT BACK TO THEM WITHIN THE WARRANTY TIME, BUT THEY HAVE GIVEN ME NOTHING BUT GRIEVE. I WOULD APPRECIATE ANY HELP I CAN GET AS I AM AFRAID OF THE VAN NOW. *JB

May 09, 2006

SERVICE BRAKES, HYDRAULIC,VISIBILITY,TIRES

1 complaint

2002 CHEVROLET CONVERSION VAN EXPRESS 1500 HAD A PROBLEM WITH THE DRIVERS SIDE WINDOW. EXPRESS WINDOW WOULD GO DOWN BUT NOT GO BACK UP. *TS THE MOTOR WAS REPLACED THREE TIMES, FINALLY THE SWITCH WAS REPLACED. THE BRAKES AND MASTER CYLINDER HAD TO BE REPLACED. THE CONSUMER WAS TOLD THE BRAKES WERE INSUFFICIENT FOR THE WEIGHT OF THE VEHICLE. THE MICHELIN TIRES ONLY LASTED 24,000 MILES. *JB

Apr 04, 2006

ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE

1 complaint

CONSUMER 2002 CHEVROLET EXPRESS ENGINE ALMOST STALLED. CONSUMER HAD FUEL INJECTION SYSTEM CLEANED. *TS THE CONSUMER WAS TOLD THERE WAS CORROSION ON THE DISTRIBUTOR CAP AND ROTOR WHICH HAD ALREADY BEEN REPLACED TWICE. *JB

Oct 27, 2005

STEERING,SERVICE BRAKES, AIR,FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM,LATCHES/LOCKS/LINKAGES,INTERIOR LIGHTING

1 complaint

WE BOUGHT OUR ASTRO VAN IN 2001, IT HAS BEEN IN THE SHOP ABOUT 22 OR 23 TIMES. MOST OF THEM MAJOR THINGS NEEDING TO BE FIXED OR REPLACED.*AK

Apr 26, 2005

SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE,POWER TRAIN,ELECTRICAL SYSTEM

1 complaint

2002 CHEVROLET EXPRESS ENGINE LOST POWER AND REAR BRAKES CAUGHT ON FAILED. *BF THE CONVERTER WAS CLOGGED WHICH RESULTED IN THE ENGINE LOSING POWER. THE CHECK SERVICE ENGINE SOON LIGHT ILLUMINATED AND THE ENGINE MISSED ON ACCELERATION. THE DEALER REPLACED THE PLUG WIRE CAP ROTOR AND DISTRIBUTOR. THE CONSUMER HEARD A SCRAPPING NOISE COMING FROM THE REAR BRAKES AND VEHICLE SHOOK WHILE BRAKING. THERE WAS VIBRATION IN THE DRIVELINE ON ACCELERATION, THE BELT WAS REPLACED. VEHICLE CONSUMED EXCESSIVE AMOUNTS OF OIL. FLUID LEAKED FROM REAR AXLE, DEALER REPLACED THE REAR AXLE SEALS. THE DEALER REPLACED THE FUEL SENDER ASSEMBLY DUE TO STALLING. THE VEHICLE BATTERY WENT DEAD AFTER THE VEHICLE SAT OVERNIGHT. CLUTCH WAS LOUD AND PROVIDED NO POWER ON HOT DAYS, THE CLUTCH FAN WAS REPLACED. THE CONSUMER REQUEST THAT THE MANUFACTURER PROVIDE A REPLACEMENT VEHICLE OR REFUND THE FULL CONTRACT PRICE PLUS INCIDENTAL COST. *NM

Mar 07, 2005

ENGINE AND ENGINE COOLING,POWER TRAIN,VEHICLE SPEED CONTROL

1 complaint

PROBLEMS WHILE USING CRUISE CONTROL ON VEHICLE.*MR WHEN THE CRUISE CONTROL WAS ENGAGED AND THE BRAKE PEDAL WAS PRESSED, THE VEHICLE TOOK A WHILE BEFORE RESPONDING AND REDUCING THE SPEED OF THE VEHICLE. WHEN THE CRUISE CONTROL WAS SET AT 65 MPH AND GOING DOWN GRADE, THE VAN WOULD PICK UP SPEED AND NEVER ADJUST BACK TO 65 MPH. IF THE SPEED WENT UP TO 70 MPH THE CRUISE CONTROL SET ITSELF AT 70 MPH. THE CONSUMER EXPERIENCED OTHER PROBLEMS WITH THE VEHICLE. THE VAN WOULD LOOSE POWER WHEN ACCELERATING. THE DEALER REPLACED THE PCM AND REPROGRAMMED IT. WHILE PERFORMING THE ENGINE DIAGNOSTIC THE TECHNICIAN FOUND THAT THE CAP AND ROTOR HAD MOISTURE IN THEM AND WERE CORRODED. THE VEHICLE'S BATTERY WAS ALSO REPLACED BECAUSE OF A DEAD CELL. *NM

Jul 19, 2004

SUSPENSION,SERVICE BRAKES, HYDRAULIC

1 complaint

LOSS OF BRAKING EFFECTIVENESS, ON INSPECTION DISCOVERED THAT OEM FRONT AXLE GREASE SEALS HAD FAILED. FAILURE HAD CONTAMINATED BOTH LEFT AND RIGHT INNER DISC BRAKE PADS AND INNER SIDE OF BOTH FRONT ROTORS WITH AXLE GREASE. REPORTED TO DEALER SERVICE AND ASKED THAT THE FAILURE BE ENTERED INTO THE GM/CHEVY SYSTEM FOR INVESTIGATION AND CORRECTION. DEALER SERVICE DEPT. DENIED ANY OTHER INSTANCES OF THIS FAILURE EXISTED AND DECLINED TO REMEDY SEAL FAILURE OR BRAKE PAD DAMAGE UNDER WARRANTY. FRONT BRAKE PADS AND GREASE SEALS WERE REPLACED AT OWNER EXPENSE.*AK

Jul 11, 2004

SUSPENSION,TIRES

1 complaint

VAN SUDDENLY DROPPED ON RIGHT FRONT SIDE AND STEERING PULLED VIOLENTLY RIGHT.*AK

Feb 16, 2004

SERVICE BRAKES, HYDRAULIC,AIR BAGS,VEHICLE SPEED CONTROL

1 complaint

I WAS IN A WRECK LAST MONDAY NIGHT WHILE DRIVING A COMPANY VAN. THE CRUISE CONTROL WHEN YOU SET IT AT A SPEED THEN GO DOWN A HILL IT WOULD GET 15-20 MILES FASTER. ANY HOW THE RIGHT FRONT TIRE WENT DOWN AND I HIT A GUARD RAIL WITH THE FRONT OF THE VAN A FIRE STARTED IMMEDIATELY BY MY LEFT FOOT AND NONE OF THE FRONT AIR BAGS DEPLOYED UNTIL THE FIRE GOT TO THEM. THE VAN ROLLED OVER ONCE AND LANDED ON ITS WHEELS THE DOORS WOULDN'T OPEN I ROLLED DOWN THE PASSENGER SIDE WINDOW AND GOT OUT THAT WAY AND THE ABS BRAKES WOULD LOCK UP WHEN YOU HAVE TO GET ON THEM REAL HARD. DT

Nov 29, 2002

Crash: 1

FUEL SYSTEM, GASOLINE,POWER TRAIN,STRUCTURE

1 complaint

CHEVYROLET DOESN'T SEEM CONCERNED. NO SAFETY DEFECT LISTED. *AK

Apr 21, 2002

2002 CHEVROLET Express Problems & Complaints

Complaints by Component

Frequently Asked Questions

How many problems does the 2002 CHEVROLET Express have?

What are the most common problems with 2002 CHEVROLET Express?

Where does this 2002 CHEVROLET Express problem data come from?

Other Years - CHEVROLET Express

Other CHEVROLET Models

Similar Brands