2007 CHEVROLET Express Problems

Complaints Reported

Complaints by Component

AIR BAGS

4 complaints

TL* THE CONTACT OWNS A 2007 CHEVROLET EXPRESS VAN. THE CONTACT STATED THAT THE AIR BAG SENSOR LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FRONT BUMPER AIR BAG SENSOR HAD MALFUNCTIONED DUE TO AN ELECTRICAL SHORT CAUSED BY MOISTURE DAMAGE. THE AIR BAG SENSOR WAS REPLACED AND THE DEFECT WAS REMEDIED. THE MANUFACTURER WAS NOTIFIED AND NO SOLUTION WAS OFFERED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 66,000.

Apr 07, 2014

TL*THE CONTACT OWNS A 2007 CHEVROLET EXPRESS. THE CONTACT STATED HE WAS INVOLVED IN A CRASH WHILE DRIVING APPROXIMATELY 35 MPH AND THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED BUT THE DRIVER SUSTAINED MINOR INJURIES. THE VEHICLE WAS TOWED TO THE CONTACTS RESIDENCE AND WAS NOT EXAMINED FOR THE CAUSE OF FAILURE. THE VEHICLE WAS NOT REPAIRED. UPDATED 07/08/11*LJ UPDATED 07/22/11

May 31, 2011

Crash: 1

Injuries: 1

THE AIR BAG LIGHT IN THE INSTRUMENT PANEL IS CONSTANTLY ON. THE PASSENGER AIR BAG STATUS LIGHT IS CONSTANTLY REPORTING NO PASSENGER, EVEN WITH AN ADULT PASSENGER SEATED. I HAVE PAID $100 FOR DIAGNOSTICS BY THE DEALERSHIP. THEY SAY THAT NONE OF THE AIR BAGS WILL DEPLOY IN CASE OF A COLLISION. THE DEALERSHIP SAYS THIS DEFECT IS NOT UNDER GM WARRANTY AND ESTIMATES THE REPAIR AT $1000. THIS CAR NEVER HAD ANY COLLISION. IT EVEN DOES NOT HAVE ANY DENT. DID YOU GET OTHER COMPLAINTS? IS THIS ACCEPTABLE? *TR

Jul 03, 2010

TL*THE CONTACT OWNS A 2007 CHEVROLET EXPRESS 1500. THE CONTACT STATED THAT THE AIR BAGS WERE DEFECTIVE. HIS VEHICLE WAS STRUCK FROM THE REAR WHILE IT WAS PARKED AND THE AIR BAGS FAILED TO DEPLOY. THE DRIVER WHO CRASHED INTO HIM WAS KILLED. FOUR PEOPLE WERE INJURED IN THE CONTACT'S VEHICLE AND FOUR PEOPLE WERE INJURED IN THE OTHER VEHICLE. THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED. THE MANUFACTURER ISSUED THE CONTACT A CASE NUMBER, HOWEVER, THEY DID NOT EXPLAIN WHY THE AIR BAGS DID NOT DEPLOY AND IF THE VEHICLE WAS INCLUDED IN ANY RECALLS. THE SPEED OF THE OTHER VEHICLE AT THE TIME OF THE CRASH WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 2,800.

Jul 30, 2007

Crash: 1

Injuries: 8

EXTERIOR LIGHTING

3 complaints

The contact owns a 2007 Chevrolet Express. The contact stated that while driving at an undisclosed speed, the rear passenger side wheel locked without warning. The vehicle was taken to the nearest service station where the rear brakes were replaced. The vehicle was then taken to the dealer where it was diagnosed that the ABS system module needed to be reprogrammed. The vehicle was repaired however, the contact stated that six months later the failure recurred. No warning lights was illuminated. The contact then stated that while driving at an undisclosed speed, he then depressed the brake pedal to stop the vehicle however, after the accelerator pedal was depressed, he noticed a substantial drag and failed to accelerate. The dealer was notified of the failure, but no further assistance was provided. The vehicle was not repaired. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 200,000.

Aug 04, 2023

LIGHT SWITCH IS MALFUNCTIONING, I REPLACED IT APPROXIMATELY 3 YEARS AGO AND I AM EXPERIENCING THE SAME PROBLEM. I THINK IT'S A MANUFACTURES DEFAULTS.

Jan 09, 2020

MOSTLY I HAVE BEEN NOTICING THAT MANY OF THE NEWER CARS (AMERICAN MADE) NO LONGER ARE USING YELLOW TURN SIGNALS AT THE REAR OF THE CARS. WHY IS THIS? *TR

Jan 21, 2009

TIRES

2 complaints

Update to case 11444012 I replaced the 2 tires and Goodyear inspected my other tires and said no problem selling 3 year old tires. Now another one of these tires is cracking. I have removed the tire and it's a clear defect causing cracks and bubbles. 245/75R16 111T SL WRL AT ADVENTURE OWL Tire failed on the inside side wall while the Van was parked for about 2 hours. Tires were purchased in 2019 but has a built year of 2016. AAA service inspected the Van and could not locate reason for issue. I also examined Ring video footage during the event and did not see anything near the Vehicle at the time of the event

Jan 28, 2022

245/75R16 111T SL WRL AT ADVENTURE OWL Tire failed on the inside side wall while the Van was parked for about 2 hours. Tires were purchased in 2019 but has a built year of 2016. AAA service inspected the Van and could not locate reason for issue. I also examined Ring video footage during the event and did not see anything near the Vehicle at the time of the event

Dec 16, 2021

SERVICE BRAKES

2 complaints

2007 CHEVROLET GM3500. CONSUMER WRITES IN REGARDS TO BRAKING SYSTEM FAILURE. THE CONSUMER STATED WHILE DRIVING THE BRAKES LOCKED UP. THE CONSUMER WAS ABLE TO PULL THE VEHICLE TO THE SHOULDER. THE BRAKE LIGHTS DID NOT ILLUMINATE. AFTER SITTING A FEW MINUTES, THE VEHICLE WENT BACK TO NORMAL OPERATION. THE BRAKE FAILURE WOULD CONTINUE TO OCCUR OFTEN. THE CONSUMER STATED THE ENGIME LIGHT WOULD ILLUMINATE WHEN THE FAILURE OCCURED. THE VEHICLE WAS REPAIRED FOLLOWING A SERVICE BULLETIN, BUT WAS TOO SOON TO TELL IF THE FAILURE WOULD RECUR.

Aug 13, 2021

MOUNTING BRACKETS FOR BOTH FRONT BRAKE CALIPER HOSES WERE BENT FORWARD, CAUSING HOSES TO CONTACT INSIDES OF FRONT TIRES WHEN WHEELS WERE TURNED. RIGHT/PASSENGER HOSE WORE THROUGH, CAUSING LOSS OF BRAKE FLUID AND LOSS OF BRAKING. DRIVER MANAGED TO STOP VEHICLE SAFELY. VEHICLE WAS THEN TOWED TO SHOP FOR REPAIRS. *TR

Mar 20, 2014

POWER TRAIN

2 complaints

TL* THE CONTACT OWNS A 2007 CHEVROLET EXPRESS. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE HESITATED TO SHIFT GEARS WITH THE ILLUMINATION OF THE CHECK ENGINE LIGHT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE IT WAS STATED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 64,000. *TR

Jul 19, 2013

TL*THE CONTACT OWNS A 2007 CHEVROLET EXPRESS 1500. ON A DRY DAY THE CONTACT HEARD METAL SCRAPING THE ROAD WHILE DRIVING 65 MPH. THE VEHICLE WAS PULLED OVER, AND THE CONTACT DISCOVERED THAT SPARKS WERE IGNITING FROM UNDERNEATH THE VEHICLE. THE CONTACT DIALED 911, AND THE VEHICLE WAS TOWED TO THE DEALER, (PATRICK CHEVROLET, WHERE IT REMAINED. THE FAILURE WAS DIAGNOSED AS THE TRANSMISSION. THE CONTACT CALLED THE MANUFACTURER, AND FILED A COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE 2,300.*AK

Apr 16, 2007

Fire: 1

STRUCTURE

1 complaint

THE PAINT WAS CONSTANTLY PEELING OFF. BIG SPLOTCHES FROM HOOD WOULD FLY UP TO WINDSHIELD AND DISTRACT WHILE DRIVING. I HAVE RECENTLY HAD WHOLE VAN PAINTED IN ORDER TO PREVENT ANY MORE OF THIS.THESE BARE SPOTS WERE RUSTING BADLY ALSO. VERY DISAPPOINTED IN THIS. I AM SEEING MANY OTHER VANS IN TOWN THAT HAVE THE SAME ISSUE.

Sep 02, 2018

ELECTRICAL SYSTEM

1 complaint

ELECTRIC WINDOW/MIRROR CONTROL PANEL AFFIXED TO THE INTERIOR OF THE DRIVER'S SIDE DOOR. ELECTRICAL THERMAL EVENT CAUSING SMOKE AND PHYSICAL DAMAGE TO THE INTERIOR SIDE OF THE DOOR AND ELECTRICAL CONTROL CLUSTER AND WIRING. VEHICLE WAS IN USE BUT WAS NOT IN MOTION AND OFF ROADWAY. CONTROL PANEL AFTERMARKET INSTALLATION PRIOR TO PURCHASE. NO PREVIOUS MAINTENANCE/REPAIR WORK PERFORMED ON DOOR OR DOOR CONTROL PANEL. PRIOR TO THE EVENT, RAIN WATER WAS OBSERVED DRIPPING ON TO THE CONTROL PANEL FROM THE ROOF WHICH OVERHANGS THE DOOR WHEN THE DOOR WAS IN THE OPEN POSITION. WE'VE EXPERIENCED WITH OTHER SIMILAR MAKE/MODEL SCHOOL BUSES ELECTRICAL SHORTS IN THE DRIVER'S SIDE DOOR CONTROL PANEL, WHICH DID NOT RESULT IN A 'THERMAL EVENT" NOR FIRE AS EXPERIENCED ON 3/27/18, BUT DID REQUIRE REPAIRS.

Mar 29, 2018

SUSPENSION,WHEELS

1 complaint

TL* THE CONTACT OWNS A 2007 CHEVROLET EXPRESS. WHILE DRIVING AT AN UNKNOWN SPEED, THE ABS WARNING LIGHT ILLUMINATED. AFTER ALL THE PASSENGERS EXITED THE VEHICLE, THE FRONT PASSENGER SIDE TIRE EXPLODED AND CAUGHT ON FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE HUB BEARING WAS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 34,000.

Jun 17, 2016

Fire: 1

AIR BAGS,SERVICE BRAKES

1 complaint

TL* THE CONTACT OWNS A 2007 CHEVROLET EXPRESS 1500. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOOR BOARD. AS A RESULT, THE CONTACT CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT AND OTHER DRIVER SUSTAINED WHIP LASH. NO MEDICAL ATTENTION WAS REQUIRED. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE HYDRAULIC BRAKE LINE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT ALSO MENTIONED THAT HE FELT LIKE THE INSTALLATION OF THE BRAKE LINING WAS FAULTY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 58,000. UPDATED 04/08/16*LJ UPDATED 05/10/18 *JB *TR

Dec 14, 2015

Crash: 1

Injuries: 2

ENGINE

1 complaint

#8 CYLINDER INTAKE VALVE SPRING FAILURE RESULTING IN THE DESTRUCTION OF INTAKE MANIFOLD. COST TO REPLACE SPRING AND MANIFOLD CAME TO$1200.00 VERY UN HAPPY. WHY DOES SOME COMPANIES USE INFERIOR PARTS RESULTING IN COSTING ME HUNDREDS. *TR

Apr 03, 2015

STEERING,SUSPENSION

1 complaint

2007 CHEVROLET EXPRESS CUTAWAY CHASSIS. CONSUMER STATES A SEVERE SHIMMY WHILE DRIVING *TGW THE CONSUMER STATED HE ENCOUNTERED A SEVERE SHIMMY ON A DOWN HILL, CURVED GOOD SURFACED HIGHWAY, WHILE TURNING LEFT ON A WINDING ROAD. AT THE TIME, THERE WAS LIGHT TO MODERATE BRAKE APPLICATION, AND THE TRANSMISSION WAS IN TOW MODE. *JB

Sep 06, 2012

ENGINE AND ENGINE COOLING

1 complaint

RADIATOR HOSE GETS DAMAGED WHEN RADIATOR FAN SHROUD TOUCHES IT REPEATEDLY THROUGH MOTOR VIBRATIONS. WE HAVE SEEN THIS ON TWO DIFFERENT VEHICLES (2007 AND 2010 MODELS) OF CHEVY EXPRESS VANS. 2010 VAN IS VIN #[XXX]. OUR MECHANIC EXPLAINED THIS TO US AND TOOK PHOTOS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Nov 18, 2011

SERVICE BRAKES, HYDRAULIC

1 complaint

TL* THE CONTACT OWNS A 2007 CHEVEROLET EXPRESS. THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH DOWN A STEEP GRADE ON A MOUNTAINOUS ROAD. WHEN THE BRAKE PEDAL WAS DEPRESSED, THE ABS WARNING INDICATOR ILLUMINATED AND THE VEHICLE BEGAN TO SHAKE VIOLENTLY. THE ABS LIGHT REMAINED ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED FOR THE FAILURE AND THE MANUFACTURER WAS NOT MADE AWARE OF THE DEFECT. THE FAILURE MILEAGE WAS 3,000.

May 24, 2011

LATCHES/LOCKS/LINKAGES

1 complaint

REAR SIDE DOORS ON MY CHEVROLET EXPRESS VAN HAVE CORRODED TO THE POINT THEY WILL NOT OPEN. *TR

Nov 30, 2009

⭐

4.9/5.0

68 reviews

Frequently Asked Questions

How many problems does the 2007 CHEVROLET Express have?

The 2007 CHEVROLET Express currently has 22 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2007 CHEVROLET Express?

The most common problems reported for the 2007 CHEVROLET Express are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2007 CHEVROLET Express problem data come from?

All problem and complaint data for the 2007 CHEVROLET Express comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.