2000 CHEVROLET Lumina Problems & Complaints

THE COOLING SYSTEM WAS LOSING ANTIFREEZE RAPIDLY, DUE TO A DEFECTIVE LOWER INTAKE MANIFOLD GASKET,BOTH THE LOWER AND UPPER INTAKE MANIFOLD GASKET HAD TO BE REPLACED. A COSTLY JOB. AS PER THE TECHNICIAN THIS ENGINE ALWAYS HAS THIS DEFECTIVE PROBLEM. *TR

MY ENGINE STALLS AT LEAST 2 TO 3 TIMES A MONTH, NOTHING HAS BEEN DONE BECAUSE IT IS AN EXPENSIVE PROBLEM... AND IT IS A MANUFACTURERS DEFECT.... *TR

LOW COOLANT LIGHT KEPT COMING ON HAD TO FILL RESIVOIR TANK ONCE A WEEK. TOOK CAR IN TO FIND THE PROBLEM LOWER INTAKE MANIFOLD GASKET LEAKING AND HAD TO BE REPLACED. *JB

I PURCHASED MY 2000 CHEVY MALIBU WITH 8,000 MILES AND STILL UNDER WARRANTY. I WAS VERY HAPPY WITH IT UNTIL RECENTLY. EVEN THOUGH I FAITHFULLY CHANGE THE OIL EVERY 3,000 MILES I AM NOW EXPERIENCING MAJOR PROBLEMS WITH 65,000 MILES ON THE VEHICLE WHICH I AM STILL PAYING OFF. I WAS TOLD BY MY MECHANIC THAT GMC HAD AN ISSUE WITH THE ENGINE THAT IS IN MY VEHICLE. IT NOW HAS AN INTAKE VALUE FAILURE AND PISTON PROBLEMS. I HAVE OWNED MANY OTHER VECHILES AND AS LONG AS I MAINTAINED THEM THEY RAN GREAT UNTIL 100,000 PLUS MILES. WHAT IS THE PROBLEM AND WHY IS THERE NOT A RECALL ON THIS ENGINE? NOT IMPRESSED. I THOUGHT GOING GMC WOULD GIVE ME A RELIABLE VEHICLE. I NOW HAVE TO PUT IN OVER $1,000 OR REPLACE THE ENGINE FOR $3,000 TO $4,000. WHEN I GO TO PURCHASE ANOTHER VEHILE I WILL KEEP THIS IN MIND!!!!!

THE INTAKE MANIFOLD GASKET ON CHEVROLET 2000 LUMINA VIN# [XXX] HAS BEEN REPLACED TWICE SINCE THE VEHICLE WAS PURCHASED. FIRST TIME UNDER WARRANTY WITH APPROXIMATELY 35,000+ MILES AND SECOND TIME WITH 78,838 MILES ON THE VEHICLE. THIS APPEARS TO BE A MANUFACTURERS DEFECT BASED ON MY EXPERIENCE AND DISCUSSIONS WITH OTHERS. THIS COMPLAINT IS WITH THE MANUFACTURER. *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

TL* THE CONTACT OWNS A 2000 CHEVROLET LUMINA. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE TRANSMISSION SHIFTED FROM FIRST TO SECOND GEAR INDEPENDENTLY AND THE VEHICLE STARTED TO VIBRATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSE THAT THE PRESSURE CONTROL SOLENOID WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO FILED A REPORT BUT DID NOT OFFER ANY FURTHER ASSISTANCE. THE CURRENT AND FAILURE MILEAGE WAS 84,000.

HAD TO CHANGE BATTERY, THIS CAUSES THE ON BOARD COMPUTER TO RESET TO ORIGINAL SETTING. THE TRANSMISSION (4T65E) IS PROGRAMMED TO MAKE SHIFTS AT CERTAIN SPEEDS IN AN ALLOTTED TIME SPAN. BECAUSE NOW, THE CAR (2000 LUMINA) IS OLDER AND THE SHIFTS ARE A LITTLE LONGER THE COMPUTER SENDS MESSAGES TO THE TRANSMISSION TO FORCE PRESSURE ON THE LINES TO CORRECT SPLIT SECOND SHIFTING. THIS CAUSES HARD SHIFTING AND GRINDING SOUNDS. I STOP THE CAR, TURN THE MOTOR OFF, THEN ON AND ITS OK AGAIN FOR A FEW MORE MILES. A TRANSMISSION SHOP WANTS $1400.00 TO FIX PROBLEM, BUT THE PROBLEM IS A NOT SO SMART COMPUTER THAT DOESN'T ALLOW FOR A CAR TO AGE. *TR

I HAVE A 2000 CHEVY LUMINA WITH 54,XXX MILES ON IT. IN 2003 WHEN IT HAD 22,XXX MILES ON IT I HAD THE TRANSMISSION WORKED ON BECAUSE IT WAS SHUTTERING AND SHIFTING HARD. IT WAS STILL UNDER WARRANTY AT THE TIME. NOW, 6 YEARS LATER I AM HAVING THE EXACT SAME PROBLEM AND AM TOLD I HAVE TO HAVE A WHOLE NEW TRANSMISSION INSTALLED. A CAR THAT HAS 54,XXX MILES ON IT AND HAS ALWAYS BEEN SERVICED ON TIME SHOULD NOT HAVE THE TRANSMISSION GO OUT. IT HAD A CODE OF 1810 WHEN DIAGNOSTICS WAS DONE TO IT. *TR

THE LEVER USED TO CHANGE GEARS BROKE OFF UNEXPECTEDLY WHEN CONSUMER WAS PUTTING VEHICLE IN PARK. TAKEN TO A MECHANIC FOR REPAIRS, AND TWO NEW PARTS AND SWITCH WERE INSTALLED IN ORDER TO CHANGE GEARS.*AK *TC

PROBLEMS WITH TRANSMISSION ON 200 CHEVROLET LUMINA.*MR THE VEHICLE'S TRANSMISSION FAILED WITH ONLY 42549 MILES. THE MANUFACTURER WAS CONTACTED AND TOLD THE CONSUMER THAT SHE WOULD POSSIBLY BE REIMBURSED FOR THE COST OF THE TRANSMISSION REPAIR. *NM

THIS CAR WILL NOT START DUE TO A DEFECT OF THE ANTI-THEFT SECURITY BUILT-IN IT. TO BE ABLE TO START THE VEHICLE I HAVE TO TURN ON THE IGNITION AND OFF AND WAIT THREE TO FOUR MINUTES TO START AND TURNS ON. THIS PROBLEM IS 90% OF THE TIME. *TR

I HAVE A 2000 MALIBU AND IT HAS 129K MILES ON IT. THE ANTI-THEFT LIGHT HAS BEEN ON FOR MONTHS AND I DIDN'T KNOW WHAT THE REASON FOR THIS WAS, BUT IT NEVER SEEMED TO AFFECT MY CAR IN ANY WAY. TODAY THE CAR TURNED ON FINE TWICE, ONCE COMING OUT OF THE HOUSE AND THE SECOND TIME COMING OUT OF THE GAS STATION. WHEN I TRY TO TURN IT ON AFTER LEAVING FROM A JOB INTERVIEW, IT CRANKS AS IF IT WANTS TO TURN ON BUT DOESN'T. IT SOUNDS LIKE IF THE GAS TANK IS ON EMPTY BUT IT'S ALMOST FULL. I CHECKED ALL CONNECTIONS AND EVEN TRIED A JUMP START AND IT DIDN'T MAKE ANY DIFFERENCE. FINALLY I GOT IT TOWED HOME AND FIND OUT ON THE INTERNET THAT CHEVY MALIBUS ARE FULL OF DEFECTS.(HTTP://WWW.AUTOSITE.COM/CONTENT/RESEARCH/FORUMS/INDEX.CFM/ACTION/POSTS/FID/1601) (INCLUDING MY AC THAT ONLY WORKS ON 3, 4, AND 5). MY ANTI THEFT DEVICE WON'T LET ME DRIVE MY OWN CAR, AND I ALREADY MISSED AN IMPORTANT CLASS. I'VE BEEN TRYING TO LEAVE THE IGNITION SWITCH IN THE ON POSITION FOR A WHILE UNTIL THE ANTI THEFT LIGHT TURNS OFF, BUT IT NEVER TURNS OFF. IT HAS BARELY STARTED WITH THIS PROBLEM TODAY, BUT AFTER READING ALL OF THE COMPLAINTS, MORE LIKE HORROR STORIES, I'M SCARED OF MY MALIBU AND I DON'T TRUST IT ANYMORE BECAUSE I KNOW IT WILL GET WORSE. I DON'T HAVE THE MONEY TO PAY THE DEALER TO FIX AN OBVIOUS PROBLEM THAT THEY KNOW EXISTS BUT WON'T ADMIT TO; THERE NEEDS TO BE A SERIOUS RECALL. *TR

ON MANY OCCASIONS THE ANTI-THEFT LIGHT ON THIS 2000 MALIBU HAS COME ON AND THE CAR WILL NOT START FOR 20 TO 30 MINUTES. ONE TIME IT CAME ON WHILE DRIVING AND THE CAR STALLED. IT HAS BEEN TO THE DEALER 3 TIMES AND THEY HAVE NOT BEEN ABLE TO FIX IT. *JB

THE IGNITION BECAME INOPERABLE. KEY WOULD NOT TURN, THE KEY CYLINDER AND SWITCH HAD TO BE REPLACED FOR THE SECOND TIME. THE FIRST TIME WAS OCTOBER OF LAST YEAR 2003. IN BOTH OCCURANCES THE VEHICLE HAD TO BE TOWED.*AK

WHEN EXITING THE CAR, PERSONS OPENING DOOR RECEIVE SHOCK. THIS IS VERY PAINFUL AND CAUSES PERSON TO JUMP. THE DEALER COULD NOT COME UP WITH ANY REASON FOR THIS AND SAID THEY COULD NOT DO ANYTHING FOR US. WE HAVE TRIED STATIC GUARD AND INSTALLATION ON A GATES STATIC STRAP TO CAR WITH NO CHANGE. ALL PARTS OF CAR APPEAR TO BE CONNECTED WHEN CHECKED FOR CONTINUITY. PLEASE LET US KNOW IF THEIR IS SOMETHING WE CAN DO OR IF THERE IS ANY OTHERS WITH THIS PROBLEM.

DT: THE CONTACT STATED THE BACK PLATE FAILED ON THE REAR BRAKES. THE VEHICLE WAS IN NEUTRAL WITH THE EMERGENCY BRAKE ON AND THE BRAKE FAILED. UPON INSPECTION IT WAS DISCOVERED THE BACKER PLATE RUSTED OUT, RESULTING IN THE BRAKE FAILURE. THE PARKING BRAKE SYSTEM WAS A COMBINATION OF BOTH DISC AND DRUM BRAKES. THERE WAS NO WARNING PRIOR TO THE COMPLETE FAILURE OF THE BACK PLATE. THE BACK PLATE HAS NOT BEEN REPLACED AT THIS TIME. EARLIER THERE WAS A FAILURE OF THE ENTIRE VEHICLE BRAKING SYSTEM. ALL FOUR BRAKE ROTORS RUSTED, RESULTING IN TOTAL BRAKE FAILURE. THE WHEEL CYLINDER SEPARATED FROM THE CALIPERS. THE ONLY WARNING LIGHT CAME AFTER THE COMPLETE FAILURE OF THE LEFT ROTOR. THE ROTORS WERE REPLACED AND THE CALIPERS WERE REBUILT. THE BRAKE PADS HAD LESS THAN 50 % WEAR BUT THEY WERE REPLACED AS WELL. *AK

I OWN A 2000 CHEVROLET ASTRO VAN WHICH I HAVE NOT BEEN ABLE TO DRIVE FOR OVER A YEAR BECAUSE OF MALFUNCTIONING ANTILOCK BRAKES. I BROUGHT IT TO BE REPAIRED LAST YEAR AND PAID OVER $800 FOR ONE SET OF BRAKES, THE OTHER SET STILL NEEDS TO BE FIXED. THE ANTILOCK BRAKES PREVENT THE VEHICLE FROM STOPPING WHEN TRAVELING AT SLOW SPEEDS. THIS IS A DEFINITE SAFETY PROBLEM. THERE HAS BEEN A SERVICE BULLETIN FOR THIS PROBLEM ON THIS VEHICLE SINCE 2002. THERE IS CURRENTLY AN INVESTIGATION OF THIS VERY PROBLEM ON SIMILAR CHEVY SUVS AND TRUCKS, BUT NOT INCLUDING THE ASTRO VAN.

EXCESSIVE BRAKE PULSATION AND VIBRATION; WITH INCREASED STOPPING DISTANCE. *AK

ONGOING PROBLEM WITH BRAKES SQUEALING WHEN STOPPING AT AN INTERSECTION AND/OR WHILE BACKING UP. DEALER NOTIFIED . FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK

WE HAD PURCHASED UNIROYAL TIRES IN OCTOBER 2002 FROM FARM AND FLEET IN LA CROSSE. AS OF AUGUST 4, 2005, ALL THE TIRES NEEDED TO BE REPLACED DUE TO THE TIRES CRACKING AND PEELING. WE TOOK THE CAR TO SEARS WHERE THEY TOLD US THEY WOULD NOT LET US DRIVE THE CAR DUE THE SEVERITY OF THE PEELING OF THE TIRES. DRIVING OUR CAR WITH THE TIRES IN THE POOR CONDITION COULD CAUSE AND ACCIDENT AND INJURY. I STARTED HAVING A PANIC ATTACK AFTER HEARING THIS NEWS. WE WERE TOLD THAT THIS IS NOT NORMAL FOR TIRES TO SHRED, CRACK, AND PEEL AT ONLY 40,000 MILES. I CALLED FARM AND FLEET WHERE WE BOUGHT THE TIRES AND HE TOLD ME "TOO BAD" AND HUNG UP ON ME. I CALLED UNIROYAL AND SHE SAID IT IS NOT THEIR PROBLEM IF OUR TIRES CRACKED, THAT'S WHAT TIRES DO. THESE TIRES THAT CRACKED, PEELED, AND SHREDDED HAVE A 75,000 MILES WARRANTY, NOONE WILL HONOR THIS WARRANTY AND WE HAD TO SPEND OVER $400 BUYING NEW TIRES. *NM

THE RIGHT FRONT TIRE BLEWOUT WHILE DRIVING CAUSING DAMAGE TO THE RIM (B.F. GOOGRICH TOURING T/A SR4, P205/70R15, DOT APM0B0110400, REPLACEMENT EQUIPMENT ON A 2000 CHEVROLET LUMINA WITH 50448 MILES).*AK *NLM

CONSUMER STATES THAT THE STEERING WOULD MAKE A POPPING SOUND WHEN TURNING. DEALER WAS NOTIFIED AND REPLACED THE STEERING GEAR BOX. NLM

CONSUMER STATES THAT THE VEHICLE WOULD MAKE A NOISE WHILE DRIVING, VEHICLE TAKEN TO THE DEALER AND HAD THE RACK AND PINION REPLACE BECAUSE IT WAS BENT. NLM

HEAT SHIELD CONTINUES TO MAKE NOISE, EVEN AFTER TURNING OFF VEHICLE. DEALER NOTIFIED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION CONCERNING THIS MATTER.*AK

POWER SLIDING DOOR OPENS AND CLOSES WHILE PARKED AND AT SPEEDS OF 5MPH. THE MANUFACTURER AND THE DEALERSHIP WERE NOTIFIED TO FIX THE PROBLEM ON 5 DIFFERENT OCCASIONS NONE OF WHICH FIXED THE PROBLEM. A LEATHER TRIM ON THE BACK SIDE OF THE FRONT PASSENGER SEAT WAS COMING UNDONE AND THE DEALERSHIP FOOLISHLY TRIED TO FIX IT WITH SILICON. I SHOULD OF STUCK WITH JAPANESE CARS.

THE CAR SHUT OFF WHILE GOING DOWN THE HIGHWAY AT 45MPH. I GOT OUT OF THE CAR, LOOKED UNDER THE CAR, AND WATER WAS POURING FROM THE FRONT OF THE MOTOR. I HAD TO HAVE TO CAR TOWED. THE MECHANIC THAT LOOKED OVER THE CAR SAID THAT THERE WERE ISSUES WITH THE INTAKE MANIFOLD AND MY GASKETS. *TR

TL* THE CONTACT OWNS A 2000 CHEVROLET LUMINA. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING WHILE DRIVING 45 MPH. THE VEHICLE WAS TOWED TO THE LOCAL MECHANIC FOR INSPECTION. THE FAILURE WAS LOCATED AT THE ENGINE INTAKE MANIFOLD, WHICH FAILED AND CAUSED SEVERAL FLUIDS TO LEAK. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 240,000.

I HAD THE LOWER AND UPPER INTAKE MANIFOLD GASKETS REPLACED ON MAY 2008, VEHICLE ONLY HAD 75000 MILES AT THAT TIME, NOW THE SAME THING IS HAPPENING AGAIN. I HAVE TO ADD COOLANT ALMOST EVERY DAY. THIS APPEARS TO BE A MANUFACTURER DEFECT. PLEASE ACKNOWLEDGE. *TR

2000 TAHOE: REAR HATCH WINDOW HINGE BROKE. IT IS MADE OF PLASTIC...PRETTY SHODDY FOR A 4W DRIVE VEHICLE. I HAVE ONLY OPENED THAT WINDOW 5-6 TIMES SINCE 2002, SO IT DEFINITELY WAS NOT ABUSED. I HAVE BEEN TOLD THAT THIS IS A DESIGN FLAW...WOULD LIKE GM TO REIMBURSE ME FOR THE $600 WINDOW PLUS HINGES (THE CHEVY DEALER QUOTED $1300.) *JB

CAR HAS 54,000 MILES WITH LIMITED NIGHTTIME USE. HAD TO REPLACE RIGHT HEADLIGHT MOTOR. 100 MILES LATER THE LEFT HEADLIGHT IS NOT WORKING CORRECTLY AND WILL NEED TO BE REPLACED. *JB

CONSUMER'S VEHICLE WAS REAR ENDED WHEN THE BACKS OF BOTH FRONT SEATS BOTH BROKE. VEHICLE WAS TOTALED. MANUFACTURER WAS CONDUCTING AN INVESTIGATION. *AK

AIR CONDITIONER FAILS TO COOL, FAILS TO COOL, WARMER AIR COMING OUT. COULDN'T FIND ANY LEAK, ADDED COOLANT, THIRD VISIT REPLACED PART OF AIR CONDITIONER, 1 YEAR LATER FAILING TO COOL AGAIN, SOME VALVE WAS STUCK, $70 NOW THAT WARRANTY IS UP, RESISTER NOT WORKING CORREXCTLY, ONLY WORKS ON HIGHEST TWO OPTIONS, WANTED TO CHARGE ANOTHER $100 FOR REPLACEMENT, CAN'T AFFORD. 2000 GEO METRO, ROGER DEAN CHEVROLET IS NOT EXACTLY A GOOD AIR CONDITIONER ANYWAY, NOT VERY COOL WHEN WORKING RIGHT. *LA

THE BUCKLE OF THE HARNESS WILL NOT FIT INTO THE LATCH BETWEEN THE CHILD'S LEG. *AK

CONCERNS ABOUT PISTONS ON VEHICLE. MR

WHEN DRIVING FROM FIRST TO SECOND GEAR VEHICLE WOULD SURGE AND FROM SECOND TO THIRD IT WOULD RESURGE. DEALER NOTIFIED, AND WAS UNABLE TO LOCATE CAUSE. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION CONCERNING THIS MATTER.*AK

PROBLEM WITH LATCHING DRIVER'S SIDE SEAT BELT. DEALER NOTIFIED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK

CONSUMER STATED THE ACCELERATOR BECAME STUCK IN BUSY TRAFFIC, CONSUMER WAS ABLE TO GET VEHICLE OFF THE ROAD, PUT IT IN NEUTRAL AND CUT IT OFF, THIS WAS THE SECOND TIME, CONSUMER COULD ALMOST FEEL HOW FAR HE COULD PRESS DOWN BEFORE IT GOT STUCK, CONSUMER THOUGHT THE CRUISE CONTROL WAS ENGAGED, BUT IT DID NOT WORK, THE ACCELERATOR GAVE A CLICK AND WOULD NOT DISENGAGE. *JG *AK