2002 CHEVROLET Monte Carlo Problems & Complaints
Real owner complaints and problems reported to the National Highway Traffic Safety Administration (NHTSA). View common issues by component.
245
Complaints Reported
Complaints by Component
ELECTRICAL SYSTEM
34 complaints
MY INSTRUMENT CLUSTER WILL RESET WHILE I AM DRIVING. THE GUAGES WILL SWEEP AND ALL THE WARNING LIGHTS COME ON AND THE CAR WILL DING AS IF IT WAS JUST STARTED HOWEVER THE CAR NEVER STALLS AND THE RADIO STAYS ON ALONG WITH EVERYTHING ELSE.
Apr 13, 2021
WAS GOING ABOUT 55-60 MPH DOWN THE HIGHWAY AND MY RPMS STARTED TO DROP AND I LET OFF GAS AND IT JUST DIED. IT CRANKS AND TURNS OVER BUT WILL NOT FIRE
Nov 05, 2019
PASSLOCK SYSTEM; CAR WILL RANDOMLY (TEMPERATURE BASED?) REFUSE TO START DUE TO POORLY CONSTRUCTED PASSLOCK SENSOR. I KEEP MY DASH APART SO I CAN POKE AT THE CONTACTS (CORRODED? CHEAP TIN PLATING) TO HOTWIRE MY CAR WHEN IT LOCKS OUT. TOOK 20 MINUTES TO GO SEE IF MY WIFE WAS OK AT THE ER, THANKS CHEVY!
Jun 25, 2017
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THERE WERE VARIOUS ELECTRICAL SHORTS IN THE VEHICLE, WHICH PREVENTED THE WINDOWS FROM GOING UP AND DOWN. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND SEVERAL INDEPENDENT MECHANICS FOR DIAGNOSTIC TESTING. THE MANUFACTURER PROVIDED NO SOLUTION AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS NOT AVAILABLE.
Apr 25, 2017
HAD ISSUES WITH ELECTRICAL IN 2015 IN WHICH GAS GAUGE AND OTHER GAUGES, SPEEDOMETER WERE "BOUNCING". AUTO REPAIR DETERMINED IT WAS THE FUEL PUMP AND REPLACED IT TO THE TUNE OF $600. THIS YEAR, WHILE DRIVING AT HIGHWAY SPEEDS WHEN CAR SUDDENLY LOOSES ALL POWER AND TURNS OFF. BROUGHT BACK TO SAME REPAIR SHOP WHO STATED BATTERY CABLES WERE LOOSE AND TIGHTENED THEM FREE OF CHARGE. NOW 4-5 MONTHS LATER AND SAME ISSUE IS OCCURRING WHICH HAPPENED 4 TIMES TODAY. TWICE WHILE MAKING A HARD TURN. TERMINALS ARE COMPLETELY TIGHT. EARLIER THIS YEAR COULD NOT TURN IGNITION KEY AND TAPPED IT WITH A HAMMER TO GET IT TO TURN. I HAVE BEEN READING QUITE A BIT ABOUT AN IGNITION SWITCH RECALL, BUT NO MENTION OF IT BY THE DEALER FOR TWO RECALL FIXES THIS YEAR REGARDING THE IGNITION KEY AND FOB, AND SOME COVER ON THE ENGINE. *TR
Dec 23, 2016
+ 29 more complaints for this component
ENGINE AND ENGINE COOLING
27 complaints
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHILE DRIVING AT ANY SPEED, THE CONTACT NOTICED A BURNING ODOR INSIDE THE VEHICLE CAUSED BY THE EMITTING OIL FROM THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THEY WERE UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 57,000. .....UPDATED 08/11/16 *BF
Jun 06, 2016
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING); HOWEVER, THE NECESSARY RECALL REPAIR PART WAS UNAVAILABLE. A REMEDY HAD NOT YET BEEN DETERMINED FOR THE RECALL. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR PART TO BECOME AVAILABLE TO THE PUBLIC. THE CONTACT ALSO STATED THAT SEVERAL APPOINTMENTS WERE SECURED TO HAVE THE VEHICLE REPAIRED; HOWEVER, THE DEALER CONTINUOUSLY CANCELLED AND RESCHEDULED APPOINTMENTS TO THEIR DISCRETION WITHOUT NOTIFYING THE CONTACT. THE CONTACT WAS UNSURE HOW THE DEALER WAS MAKING APPOINTMENTS FOR REPAIRS WHEN THERE WAS NO REMEDY AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE, BUT PROVIDED NO ASSISTANCE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 05/11/16*LJ UPDATED 07/251/6.*JB
Mar 30, 2016
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHILE DRIVING APPROXIMATELY 65 MPH, THE TURN SIGNAL WAS ENGAGED AND IMMEDIATELY THE ENGINE STALLED WITHOUT WARNING. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND AFTER NUMEROUS ATTEMPTS THE VEHICLE RESTARTED AND THE CONTACT WAS ABLE TO RESUME DRIVING. THE INTERMITTENT FAILURE OCCURRED WHENEVER THE VEHICLE WAS IN OPERATION. THE FAILURE WAS NOT DIAGNOSED NOR REPAIRED. THE DEALER WAS NOTIFIED AND INFORMED HIM THERE WERE NO RECALLS PERTAINING TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 105,000.
Sep 20, 2011
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THERE WAS AN ABNORMAL RATTLE COMING FROM THE ENGINE WHEN FIRST STARTING. THE NOISE WOULD DIMINISH ONCE THE ENGINE WAS WARMED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE SHE WAS INFORMED THAT COOLANT WAS LEAKING INTO THE OIL. THE ENGINE LIFTERS WERE REPLACED. THE FAILURE RECURRED WITHIN 2.5 YEARS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE SHE WAS INFORMED THAT THE FAILURE COULD POTENTIALLY LEAD TO VARIOUS OTHER ENGINE, TRANSMISSION AND STEERING ISSUES. THE VEHICLE WAS THEN TAKEN TO AN INDEPENDENT MECHANIC WHERE THE UPPER AND LOWER INTAKE GASKETS WERE REPLACED. SHE ALSO STATED THAT THE VEHICLE WAS DRIVING AS IF IT WAS LOSING POWER. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CATALYTIC CONVERTER WAS REPLACED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 45,000 AND THE CURRENT MILEAGE WAS 85,000.
Aug 27, 2010
2002 CHEVROLET MONTE CARLO. ONLY HAS 59,000 MILES. CAR STALLED IN TRAFFIC. NO CRASH/ACCIDENT RESULTED. INTAKE GASKET LEAKED ANTI-FREEZE INTO ENGINE AND OIL LUBRICATION SYSTEM. THE ANTI-FREEZE GOT INTO THE BALL BEARINGS (AS WELL AS REST OF ENGINE) AND CAUSED CORROSION DAMAGE AND MISFIRES. THE ENGINE THREW A ROD. THE NEAREST CHEVROLET DEALERSHIP SAYS THAT THE ENGINE MUST BE REPLACED, AND WILL COST $5,000 DOLLARS. WARRANTY IS NO LONGER ACTIVE DESPITE LOW MILEAGE DUE TO NUMBER OF YEARS THAT HAVE PASSED, NOR WILL THEY OFFER A DISCOUNT. HOWEVER, THIS PROBLEM IS A NOTORIOUS PROBLEM WITH THE 3.4L V6 ENGINE OFFERED BY CHEVROLET/HM. HOWEVER, THEY REFUSE TO ACKNOWLEDGE THE PROBLEM DESPITE THE FACT THAT THOUSANDS OF COMPLAINTS ARE LISTED ALL ACROSS THE INTERNET ON THIS SPECIFIC ISSUE. THIS ISSUE CAN ALSO CAUSE MANIFOLD EXPLOSIONS AND COLLAPSES AND RELATED ENGINE FAILURES. *TR
Jul 08, 2010
+ 22 more complaints for this component
EXTERIOR LIGHTING
27 complaints
TURN SIGNALS FAIL TO WORK AND HEADLIGHTS GO OFF WHEN YOU ARE DRIVING ON INTERSTATE OR LOCAL ROADS. SOMETIMES THE HEADLIGHTS WILL COME BACK ON IN A FEW SECONDS, OTHER TIMES IT TAKES AS LONG AS THIRTY SECONDS
May 22, 2016
HEAD LIGHTS ON MY MONTE CARLO 2002 THERE HAS ALWAYS BEEN SOMETHING NOT RIGHT. WHEN I BOUGHT THE CAR ONE NIGHT WHEN I WAS DRIVING OUT THE HIGHWAY AND ALL OF A SUDDEN THE LIGHTS JUST GO OFF SCARING ME TO DEATH. IN A FEW SECONDS THEY CAME BACK ON. I HAVE HAD THIS DO THIS TO ME SEVERAL TIMES I BOUGHT THE CAR IN 2003. NOW ON AUGUST 28TH 2010 I HAD WENT TO A FRIENDS HOUSE AND LATER THAT NIGHT WHEN I WENT TO LEAVE THE LIGHTS DIDN'T WORK AT ALL UNLESS I HELD THE LIGHT SWITCH ON THE COLUMN FOR BRIGHT OR DIM. SO NOW THAT IS THE ONLY WAY I HAVE HEAD LIGHTS NOW IF I HOLD THE SWITCH ON THE STEERING COLUMN SO I DON'T GO TO FAR AT NIGHT. DON'T HAVE THE MONEY TO FIX THEM. THERE NEEDS TO BE A RECALL ON THIS I ALSO KNOW SOMEONE ELSE THAT HAS A MONTE CARLO AND HAS THE SAME PROBLEM BUT HERS JUST GOES OFF ON HER LIKE MINE USE TO. *TR
Oct 13, 2010
HEADLIGHTS GO COMPLETELY OUT WHEN SWITCHING TO OR FROM HIGH AND LOW BEAM. RETURNING SWITCH TO PREVIOUS BEAM WILL GENERALLY MAKE THEM START WORKING AGAIN. *TR
Aug 19, 2010
MY TURN SIGNAL LIGHTS DON'T WORK SOMETIMES, I HAVE TO DEPRESS THE HAZARD LIGHT BUTTON FOR A COUPLE SECONDS AND THE THEY WORK FOR A WHILE BUT THE PROBLEM KEEPS COMING BACK, I HAVE READ ABOUT MANY COMPLAINT ABOUT THE HAZARD LIGHT SWITCH BEING THE PROBLEM BUT I THINK THE MANUFACTURER OF THE VEHICLE SHOULD BE RESPONSIBLE FOR THE REPAIR. I OWN A 2002 CHEVROLET MONTE CARLO. *TR
Aug 18, 2010
TURN SIGNALS WILL NOT ALWAYS WORK. REPLACED THE HAZARD/SIGNAL SWITCH LOCATED BEHIND THE DASH ONLY TO HAVE THE SAME PROBLEM. PRESSING ON THE DASH NEAR THE HAZARD SWITCH OR PRESSING THE HAZARD SWITCH WILL RETURN SIGNAL TO NORMAL OPERATION FOR A SHORT TIME. WHILE I WAS REPLACING THE ORIGINAL, I NOTICED PLACING A VERY SLIGHT PRESSURE ON THE SWITCH ASSEMBLY WILL CAUSE THE SIGNAL TO EITHER STOP OR START WORKING. I BELIEVE THE PROBLEM IS WITH BOTH THE SWITCH DESIGN AS WELL AS THE DASHBOARD DESIGN. HOT/HUMID WEATHER APPEARS TO IRRITATE THE SITUATION CAUSING FAILURE MORE OFTEN. RESEARCHING THE PROBLEM VIA WEB SEARCHES FINDS MANY OWNERS WITH THE SAME PROBLEM. THIS PROBLEM ALSO SEEMS TO BE COMMON TO MANY GM MODEL CARS. *TR
Aug 18, 2010
+ 22 more complaints for this component
ENGINE
22 complaints
2002 CHEVROLET MONTE CARLO. CONSUMER WRITES IN REGARDS TO ENGINE FAILURE AND REQUESTS REIMBURSEMENT FOR ENGINE REPAIRS. *SMD THE CONSUMER STATED THE ENGINE FAILED WHEN OIL GOT ONTO THE ENGINE AND CAUGHT FIRE. THE CONSUMER HAD NOT RECEIVED A RECALL UNTIL AFTER THE FAILURE. THE CONSUMER HAD THE ENGINE REPLACED. THE CONSUMER WOULD LIKE TO BE REIMBURSED FOR THE COST OF THE ENGINE REPLACEMENT. *JS
Jun 08, 2017
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHEN THE VEHICLE WAS STARTED, THE CONTACT HEARD A LOUD POPPING SOUND. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE FROM THE ENGINE COMPARTMENT. THE FIRE DEPARTMENT WAS NOTIFIED AND WAS ABLE TO EXTINGUISH THE FIRE. THERE WERE NO INJURIES AND A FIRE REPORT WAS NOT FILED. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED PER NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.
May 22, 2017
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHILE THE VEHICLE WAS UNDERGOING A ROUTINE INSPECTION, THE TECHNICIAN NOTICED THAT THE BACK COVER GASKET WAS LEAKING OIL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 21,571.
Nov 15, 2016
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING) AND STATED THAT THE PART NEEDED TO PERFORM THE RECALL REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
Mar 21, 2016
TL* THE CONTACT OWNED A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH, WHEN THE VEHICLE BEGAN TO SMOKE BOTH INSIDE THE VEHICLE AND UNDER THE HOOD OF THE VEHICLE WITHOUT WARNING. THE CONTACT MERGED TO THE SHOULDER OF THE ROAD AND EXITED THE VEHICLE ALONG WITH ALL THE OTHER OCCUPANTS. A FIRE STARTED UNDER THE HOOD OF THE VEHICLE. THE CONTACT ATTEMPTED TO PUT OUT THE FIRE HOWEVER, WAS UNABLE TO LIFT THE HOOD OF THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE VEHICLE WAS TOWED AND DEEMED TOTALED. THE TWO OCCUPANTS RECEIVED SMOKE INHALATION AND SLIGHT BURNS TO THEIR ARMS. NO MEDICAL ATTENTION WAS NEEDED. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.
Mar 10, 2016
+ 17 more complaints for this component
AIR BAGS
15 complaints
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT WAS DRIVING 29 MPH AND CRASHED INTO ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED INJURIES TO THE CHEST, LEGS AND SHOULDER. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 65,000. UPDATED 03/05/14*LJ
Jan 22, 2014
TL*THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHEN THE VEHICLE STOPPED THE FRONT AIR BAGS DEPLOYED. THE MANUFACTURER HAD AN INSPECTOR COME OUT TO INSPECT THE VEHICLE AND CONFIRMED THAT THERE WAS A FAULTY AIR BAG SYSTEM. THE MANUFACTURER STATED THAT THEY WOULD PURCHASE THE VEHICLE SINCE REPAIRING IT WAS NOT AN OPTION. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 124,314.
Dec 20, 2010
MY AIRBAG LIGHT KEEPS COMING ON AT TIMES. THIS IS THE 3RD TIME THAT THIS HAS HAPPENED. SHOULD THIS BE RECALLED? SOME CARS LIKE MINE HAVE BEEN RECALLED FOR AIR BAGS BUT I WAS TOLD MINE WASN'T. *TR
Apr 22, 2009
WAS IN A COLLISION WHICH I WAS REARENDED THEN PUSHED INTO ANOTHER VEHICLE AND NO AIR BAGS DEPLOYED. *TR
Oct 15, 2008
TL*THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHILE THE CONTACT'S SPOUSE WAS BACKING THE VEHICLE UP, THE DRIVER SIDE AIR BAG DEPLOYED WITHOUT WARNING. THERE WERE NO INJURIES. THERE IS A RECALL ON THE AIR BAG, BUT NOT THE DEPLOYMENT. THE RECALL NUMBER WAS UNKNOWN. THE CURRENT MILEAGE WAS 90,407 AND FAILURE MILEAGE WAS 79,000.
Jul 21, 2008
+ 10 more complaints for this component
SERVICE BRAKES, HYDRAULIC
14 complaints
2001-2002 GM MODELS, ABS SYSTEM MALFUNCTIONING, RANDOMLY TURNING ON. HEARD MANY PROBLEMS ABOUT THIS, NEEDS TO BE FIXED. *TR
Oct 11, 2009
ON OUR 2002 CHEVROLET MONTE CARLO THE SERVICE TRACTION SYSTEM AND ABS LIGHT COMES ON. NOW THE BRAKES OCCASIONALLY FEEL LIKE THEY ARE TRYING TO LOCK UP WHEN COMING TO A STOP. A MECHANIC SAID IT WAS ABOUT $1500.00 TO REPAIR BUT IT WOULD BE FINE WITHOUT REPAIR. NOW WE ARE NOT SO SURE. OTHERS HAVE SAID THAT EVEN DEALERSHIPS DON'T KNOW HOW TO FIX THE PROBLEM. CHANGING THE BRAKE PADS AND ROTORS WORKS FOR A VERY SHORT TIME THEN THE LIGHTS COME BACK ON. *TR
Mar 05, 2009
TRAC OFF AND ABS LIGHTS STAY ON AND THE MESSAGE CENTER SAYS SERVICE TRACTION SYSTEM. WENT ON LINE AND NOTICED THAT A LOT OF PEOPLE ARE EXPERIENCING THE SAME PROBLEM. THEY HAVE TRIED TO GET THE PROBLEM FIXED WITHOUT SUCCESS. COULD BE A POTENTIAL SAFETY ISSUE. *TR
Nov 17, 2007
TL*THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHILE BRAKING FROM 40 MPH, THE VEHICLE MADE A LOUD CLICKING NOISE. THE VEHICLE WAS DIFFICULT TO BRAKE AND THE PEDAL EXTENDED TO THE FLOORBOARD WHEN DEPRESSED. THE VEHICLE WAS TAKEN TO A MECHANIC FOR INSPECTION AND THE TIRES WERE ROTATED AND THE BRAKES WERE INSPECTED, HOWEVER, THE FAILURE CONTINUED. THE DEALER STATED THAT HER VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 04V287000 (SERVICE BRAKES, HYDRAULIC). THE POWERTRAIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 64,000 AND FAILURE MILEAGE WAS 62,000.
Oct 03, 2007
VEHICLE HAS HAD TO HAVE BRAKE ROTORS REPLACED 5 TIMES IN 5 YEARS, AND TURNED 3 OTHER TIMES. DEALERSHIP AND PRIVATE MECHANIC HAVE SAID REPEATEDLY THAT THEY SEE A LOT OF THIS AND THAT IT IS A FACTORY PROBLEM, BUT NO ONE SEEMS TO KNOW WHAT THE PROBLEM IS OR HOW TO FIX IT OTHER THAN 300-400 AT A TIME. *TR
Sep 17, 2007
+ 9 more complaints for this component
STEERING
8 complaints
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE STEERING WHEEL BECAME LOOSE. THE CONTACT STATED THAT THE STEERING WHEEL STARTED TO FUNCTION ABNORMALLY. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 08E063000 (STEERING) AND 09E005000 (STEERING). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 106,000.
Aug 26, 2015
I PURCHASED THE VEHICLE IN MAY AND SINCE THEN I BEEN HEARING THIS CLUNKING NOISE COMING FROM THE STEERING COLUMN. I CALLED GM AND THEY TOLD ME THAT IT WAS THE INTERMEDIATE STEERING SHAFT THAT NEED TO B REPLACED BECAUSE THEY GOT OUT A LOT ON THE VEHICLES. I TOLD THEM OF THEY KNOW THAT Y DIDN'T THEY RECALL THEM AND THE GUY TOLD ME BECAUSE THE SAFETY COMMISSION NEVER TOLD THEM TO. IM VERY UPSET AND FEEL THAT THIS IS A SAFETY ISSUE! I REPLACED THIS PIECE NUMEROUS TIME AND IT KEEPS MAKING THIS NOISE AGAIN! I DON'T HAVE MONEY LIKE THAT TO KEEP REPLACING THIS PART. PLEASE HELP ME BY RECALLING THIS PART BECAUSE MY KIDS ARE A FACTOR HERE AND THIS CAN BE A MAJOR ACCIDENT. *TR
Nov 16, 2012
NOTICED A KNOCKING SOUND IN THE STEERING COLUMN AT A VERY LOW MILEAGE (25000?) AND INQUIRED OF THE DEALER. TOLD THEY COULD FIND NOTHING WRONG.. HAD IT CHECKED BY AN AFTERMARKET REPAIR SHOP AT ABOUT 40,000 AND WAS TOLD THEY COULDN'T FIND THE PROBLEM BUT THAT CHEVY'S WERE HAVING A REAL BAD PROBLEM WITH THEIR STEERING COLUMNS.. VEHICLE NOW HAS 56,000 AND AM NOW TOLD BY CHEVY DEALER I NEED TO REPLACE ENTIRE STEERING COLUMN AND RACK AND PINION AT MY EXPENSE. DEALER MENTIONED THIS IS VERY COMMON PROBLEM BUT DIDN'T KNOW OF ANY RECALLS YET. COST ESTIMATE IS $1000.00. *TR
Nov 16, 2009
MY 2002 CHEVY MONTE CARLO SS HAS A CLUNKING SOUND COMING FROM THE STEERING, I HAD THIS FIXED 2 1/2 YEARS AGO AND IT HAS BEEN HAPPENING AGAIN NOW FOR ABOUT 8 MONTHS. I WAS WAITING FOR A RECALL BUT HAVE HEARD NOTHING YET. *TR
Sep 23, 2008
2002 CHEV MONTE CARLO SS EXPERIENCED "POPPING" IN STEERING WHEEL AT 21,862 MILES AND AGAIN AT 45,299 MILES. BOTH TIMES DEALER INVOICE INSINUATED THAT STEERING SHAFT WAS REPLACED. AT 84,000 MILES THIS HAPPENED AGAIN. TOOK BACK TO DEALER WHO TOLD ME THAT IN FACT THEY FOLLOWED THE GM SERVICE BULLETINS AT THE TIME AND ONLY LUBED THE STEERING SHAFT. A SERVICE BULLETIN FROM 8/1/04 SAID TO REPLACE, BUT THIS WAS AFTER THE SECOND INCIDENT AND NO ONE CALLED TO LET ME KNOW (AND OF COURSE I WAS UNDER THE IMPRESSION THAT THE REPLACEMENT HAD ALREADY OCCURRED.) THE STEERING WHEEL FELT VERY LOOSE AND UNSTABLE AND I FEEL IF LEFT UNCHECKED COULD HAVE RESULTED IN FAILURE AND ACCIDENT. *NM
Jul 31, 2005
+ 3 more complaints for this component
ELECTRICAL SYSTEM,ENGINE
6 complaints
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE JERKED AND THE COMPUTER TURNED ON AND OFF AS SMOKE EMITTED UNDER THE HOOD. THE CONTACT EXTINGUISHED THE FIRE. A POLICE AND A FIRE REPORT WERE NOT FILED AND THERE WERE NO INJURIES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE FAILURE MILEAGE WAS APPROXIMATELY 119,000.
Jan 19, 2016
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHEN THE IGNITION WAS TURNED TO THE ON POSITION, THE VEHICLE DID NOT START UNLESS THE CONTACT WAITED FOR TEN MINUTES. THE CONTACT STATED THAT THE KEY WAS REMOVED WHILE THE IGNITION WAS TURNED TO THE ON POSITION AND THE ENGINE REMAINED RUNNING. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000.
May 19, 2015
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE BRAKE PEDAL WAS DEPRESSED BUT THE VEHICLE FAILED TO RESPOND AND STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTARTED AFTER MULTIPLE ATTEMPTS. IN ADDITION, THE ENTIRE INSTRUMENT PANEL FAILED. ON ONE OCCASION, THE VEHICLE COASTED PAST A STOP SIGN AND ANOTHER VEHICLE CRASHED INTO THE FRONT DRIVER SIDE OF THE VEHICLE. A POLICE REPORT WAS FILED AND THE CONTACT SUSTAINED NECK INJURIES THAT DID NOT REQUIRE MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO A DEALER BUT THE FAILURE WAS UNABLE TO BE DETERMINED. THE CONTACT RECEIVED NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFUSED TO COMPENSATE THE CONTACT. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.
Sep 30, 2014
WE HAVE BEEN HAVING PROBLEMS WITH OUR CAR STARTING. THE BATTERY HAS BEEN REPLACED. WE HAVE DISCONNECTED THEN RECONNECTED THE BATTERY, SOMETIMES THIS WORKS TO START THE CAR OTHER TIMES IT DOES NOT. THE POWER LOCKS NO LONGER WORK. ONE DAY THE SECURITY LIGHT COMES ON, SOMETIMES ITS NOT YESTERDAY, WE COULDN'T EVEN GET THE CAR TO START. TODAY, THE CAR WAS RUNNING AND THE CLUSTER GAUGES WERE NOT EVEN WORKING. WE BOUGHT THIS CAR BRAND NEW OUT OF THE SHOWROOM. WHAT A LEMON IT TURNED OUT TO BE. SADLY, IT NOW SITS IN OUR DRIVEWAY AS IT IS NOT DEPENDABLE TO DRIVE ANYWHERE. THERE IS A RECALL TO REPLACE THE KEY RINGS, AND AN INSET IN THE KEY SLOT OR A COVER ON THE KEY HEAD INSTEAD GM SHOULD BE RECALLING THESE MODELS TO REPLACE THE IGNITIONS, SINCE THERE ARE OTHER PEOPLE POSTING ONLINE ABOUT THESE SAME ISSUES. *TR
Sep 10, 2014
DRIVING ON HWY 31 IN MCHENRY IL 60050 IGNITION TURNED OFF WITH NO WARNING. LOST ALL POWER STEERING BRAKES CAR STOPPED BY RUBBING INTO CURB. WAS NEARLY REAR ENDED BY A PICK UP TRUCK WHICH HAD NO WARNING THAT I WAS SUDDENLY STOPPING TRYING TO MANEUVER OF TRAFFIC. WITH THE CURB AND NO POWER I HAD NO WAY TO GET OFF THE ROAD. *TR
Jun 24, 2014
+ 1 more complaint for this component
ELECTRICAL SYSTEM,EXTERIOR LIGHTING
5 complaints
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE HEAD LAMP LENSES HAD BEEN OXIDIZED AND THAT THERE WAS A FILM BUILD UP WHICH AFFECTED THE VISIBILITY OF THE LOW BEAMS WHILE THE VEHICLE WAS IN MOTION CAUSING THE LIGHTING TO BE DIM. THE CONTACT ALSO STATED THAT THE KEY LESS ENTRY FUNCTION FAILED INTERMITTENTLY AND THAT UPON ENTERING THE VEHICLE, IT WOULD NOT START. THE CONTACT WAS ABLE TO UTILIZE THE OWNERS MANUAL TO OVERRIDE THE SYSTEM BY EITHER DISCONNECTING AND RECONNECTING THE BATTERY CABLE OR RESETTING THE COMPUTER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 2,400.
Apr 28, 2016
THE POWER WINDOWS STOPPED WORKING ,AND THEN THE SECURITY SYSTEM WOULDN'T LET ME START THE CAR. ALSO THE CAR STARTED RUNNING HOT FOR NO REASON AT ALL. *TR
Jan 20, 2015
I HAVE A 2002 CHEVROLET MONTE CARLO LS. ABOUT 1 YEAR AGO MY TURN SIGNALS QUIT WORKING RANDOMLY. IT SEEMED TO BE THE WORST ON HOT DAYS. I WOULD LEAVE MY HOME OR WORK WITH THEM WORKING PROPERLY AND THEN AT A RANDOM POINT DURING MY DRIVE THEY WOULD NO LONGER WORK. GM HAS RECALLED OTHER MAKES AND MODELS FOR SIMILAR PROBLEMS. HOWEVER, THE MONTE CARLOS HAVE NEVER BEEN RECALLED. AFTER SEARCHING FOR A POTENTIAL SOLUTION TO THIS PROBLEM, I HAVE FOUND THAT IT SEEMS TO BE A VERY COMMON PROBLEM ON MANY SIMILAR CARS THAT GM MAKES. MOST PEOPLE HAVE SAID THAT IT IS RELATED TO THE HAZARD SWITCH IN THE DASH BOARD. THIS IS A RELATIVELY CHEAP FIX HOWEVER IT IS ALSO A MAJOR SAFETY HAZARD SINCE I NEVER KNOW WHEN THE TURN SIGNALS WILL OR WILL NOT WORK. IT SEEMS TO BE LUCK OF THE DRAW, WHICH IS VERY DANGEROUS. THANK YOU FOR YOUR CONSIDERATION ON THIS PROBLEM. *TR
Sep 07, 2010
TURN SIGNAL FAILURE: BEGINNING IN 2005 THROUGH TO 2007 THE TURN SIGNALS WOULD WORK INTERMITTENTLY. WHILE UNDER WARRANTY THE VEHICLE WAS TAKEN TO THE DEALERSHIP. THEY INDICATED THAT THERE WAS NO PROBLEM. ONCE WARRANTY WAS EXPIRED THERE WAS NOTHING I COULD DO. I DID FIND THAT TURNING THE HAZARD SIGNALS ON FOR 5-10 SECONDS WOULD SOMETIMES CORRECT THE PROBLEM AND THE TURN SIGNAL WOULD WORK. FINALLY AFTER MANY HOURS SEARCHING THE INTERNET I FOUND SEVERAL POSTINGS INDICATING THAT THERE WAS A FAULTY HAZARD LIGHT SWITCH, THE TURN SIGNALS ARE ALSO CONTROLLED BY THE HAZARD LIGHT SWITCH. IN OCTOBER 2007 I SPENT $399 TO HAVE THE HAZARD LIGHT SWITCH REPAIRED. PLEASE INSIST THAT THE DEALERSHIP REPLACE THE HAZARD LIGHT SWITCH AND NOT ADD ON ADDITIONAL PARTS LIKE THE TURN SIGNAL ARM ETC. MY DEALERSHIP FIRST QUOTED ME $850 STATING THAT THE TURN SIGNAL ARM MUST ALSO BE REPLACED TO CORRECT THE ISSUE. SINCE THE REPAIR ALL IS FINE. I DO BELIEVE THAT GM/CHEVROLET SHOULD BE RESPONSIBLE FOR THE COST OF REPAIR SINCE IT IS A DEFECT IN THEIR DESIGN.*TR
Sep 17, 2008
DT: 2002 CHEVROLET IMPALA LS. THE CONSUMER STATED CAR DEVELOPED A SPORADIC FAILURE OF TURN SIGNALS. THIS HAS BEEN HAPPENING FOR ABOUT 3 WEEKS. INVOLVED LEFT AND RIGHT TURN SIGNALS. THE CONSUMER CONTACTED CHEVROLET, THEY TOLD THE CONSUMER TO CONTACT THE DEALER, IMPERIAL CHEVROLET. HOWEVER, THE DEALER TOLD THE CONSUMER SHE WOULD HAVE TO PAY $46.00 JUST TO LOOK AT CAR. THE CONSUMER STATED THAT AN ARTICLE IN LOCAL NEWSPAPER STATED THERE HAS BEEN A TREND OF FAULTY IGNITION SWITCHES IN THIS MODEL VEHICLE. WHEN THE CONSUMER CALLED IMPERIAL CHEVROLET THEY STATED THEY WERE WELL AWARE OF THE PROBLEM WITH THE FAULTY IGNITION SWITCHES. *AK
Sep 26, 2005
VISIBILITY
5 complaints
WINDOW REGULATOR HAS GONE OUT THREE TIMES ON TWO WINDOWS. 2008, 2010, 2014. THE WHOLE SYSTEM IS A BAD DESIGN AND CABLE JUMPS TRACK AT THE LEAST OF BIT JARRING. THIS IS A SCARY THING TO HAPPEN AS WHEN THE WINDOW FALLS IT IS A LOUD POPPING SOUND. TWICE WINDOW FELL DOWN AT CAR WASH. ONCE TRAVELING 55 MILES AN HOUR. THOUGHT SOMEONE SHOT AT THE CAR. IF WINDOW FALLS WHILE NO ONE IS AROUND THEFT COULD OCCUR OR IF RAINING IT WILL SOAK YOUR CAR. SOMEONE NEEDS TO INVESTIGATE HOW THESE WINDOW REGULATORS ARE MADE BECAUSE THEY ARE NOT SAFE. TALKED TO PERSON WHO INSTALLED THEM AND HE HAD TWO REGULATORS GO OUT ON IS F150 FORD TRUCK AND HE REPORTED IT TOO. ALSO HAPPENED TO MY FAMILY MEMBER TOO TWO OF HIS REGULATORS HAD TO BE REPLACED ON HIS F150 TRUCK. I DON'T KNOW HOW MANY COMPLAINTS YOU RECEIVE BUT SOMETHING HAS TO BE DONE. THIS A SAFETY HAZARD. ALSO TURN SIGNAL INTERMITTENTLY GOES OUT AND I NOTED THAT THIS A MAJOR COMPLAINT TO YOUR SITE. *TR
Feb 18, 2014
MY CHEVROLET WINDOW IS BAD AND IT THREW A ROD FOR NO APPARENT REASON. *TR
Aug 04, 2010
TL*THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHILE DRIVING APPROXIMATELY 55 MPH IN RAINY WEATHER CONDITIONS, THE WINDSHIELD WIPERS WORKED NORMALLY. WHEN THE WIPERS WERE DEACTIVATED, THE BLADES REMAINED IN AN UPWARD POSITION. THE FAILURE WAS ANNOYING AND HINDERED VISIBILITY. THE VEHICLE HAS NOT BEEN REPAIRED. THE CONTACT WAS CONCERNED OF THE SAFETY RISK INVOLVED. THE CURRENT MILEAGE IS 90,000 AND THE FAILURE MILEAGE WAS 88,000. UPDATED 10-30-08 *BF THE CONSUMER STATED THE WINDSHIELD ARE IN AN UPWARD POSITION WHEN THEY ARE NOT IN USE. UPDATED 10/31/08. *JB
Sep 24, 2008
WINDSHIELD WIPER ARM HAD TO BE REPLACED SINCE IT STARTED TO SCRAPE THE WINDOW.*AK
Mar 31, 2005
REAR VIEW MIRROR DOES NOT DIM AUTOMATICALLY WHEN EXPOSED TO LIGHT. CONSUMER IS TEMPORARILY BLINDED BY OTHER DRIVERS. COULD CAUSE A BAD ACCIDENT. *AK SINCE CALLING IN THIS REPORT, THE DEALER HAS REPLACED THE MIRROR. THE REPLACEMENT MIRROR OPERATES BETTER THAN THE ORIGINAL. IT STILL HOWEVER HAS THE EFFECT OF BLINDING THE DRIVER. *JG
Jun 12, 2002
STRUCTURE
5 complaints
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT AFTER SHIFTING INTO DRIVE, THE VEHICLE ACCELERATED RAPIDLY AND INDEPENDENTLY. THE FAILURE WAS CAUSED BY THE FLOOR MATS, WHICH HAD BECOME STUCK OVER THE ACCELERATOR PEDAL. THE CONTACT WAS ABLE TO STOP VEHICLE AND REMEDY THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 19,000. *TR UPDATED 07/09/13*LJ UPDATED 07/15/2013 *JS
May 15, 2013
I BOUGHT MY 2002 MONTE CARLO NEW,,,MY COMPLAINT IS MY CAR IS GARAGE KEPT,,,I WASH IT ,,DRY IT,,KEEP IT CLEAN,,,,IT'S STARTING TO RUST,,,THE TIRE FENDERS,,,THE GAS DOOR. THE PAINT IS BUBBLING,,,THIS SHOULDN'T BE SINCE GARAGE KEPT,,IN WINTER GET SALT OFF,,,SUMMER ALSO GARAGE KEPT EXCEPT IF OUT AND ABOUT,,,,CHEVY MORE OR LESS SAYS TO BAD,,,SO SAD,,,,WE PAY BIG BUCKS FOR THESE CARS...WHAT GIVES? *TR
Oct 19, 2009
I HAVE A 2002 MONTE CARLO .THE PROBLEM WITH THE CAR IS THAT BOTH DOORS PASSENGER AND DRIVER DOOR HAS DAMAGED AND BENDED BOTH FENDERS. I HAVE SEEN A LOT OF MONTE CARLO CARS LIKE MINE. WITH THE DOORS BENDING THE FENDERS IT'S HARD TO GET IN AND OUT OF MY CAR AND IT ALSO CAUSES WATER TO GET IN MY DOORS EVERY TIME IT RAINS CAUSING MY SPEAKERS TO NOT PLAY RIGHT. *TR
Jul 19, 2009
THE ENTIRE VEHICLE UNDER CARRIAGE FAILED, WHICH RESULTED IN THE TIE ROD, AND CONTROL ARM BENDING AT A 25 MPH IMPACT. *JB
Mar 12, 2003
WHEN TURNING STEERING WHEEL IT MAKES A LOUD SNAPPING NOISE IN THE FRONT SUSPENSION. DEALER INDICATED FRONT SUBFRAME MAKING THE NOISE, BUT SO DO SEVERAL OTHER CARS OF SAME MAKE AND MODEL. NO SOLUTION OFFERED BY MANUFACTURER. OWNER HAS CONTACTED NEW YORK'S ATTORNEY GENERAL'S OFFICE. *AK *MJ
May 29, 2002
POWER TRAIN
4 complaints
WHEN WARM FROM A STANDING STOP THE TRANSMISSION WILL SHUDDER UNDER HARD ACCELERATION . ALSO UP SHIFTS BECOME ERRATIC AND VERY HARSH.
Sep 09, 2015
I PURCHASED MY 2002 CHEVROLET IMPALA LS IN DECEMBER, 2004. GREAT LOOKING VEHICLE WITH NUMEROUS PROBLEMS. THE MOST RECENT AND SEVERE HAS COME OVER THE LAST FEW DAYS. WHILE ACCELERATING ON AN ENTRANCE RAMP, THE CAR WILL NOT SHIFT PROPERLY; VERY ROUGH AND THE RPM'S GO TO 4000 OR ABOVE BEFORE SHIFTING OR IF I LET OFF THE ACCELERATOR. I AM TERRIFIED THAT THE TRANSMISSION IS GOING TO COME OUT COMPLETELY WHILE DRIVING WITH MY FAMILY IN THE VEHICLE; I AM TAKING THE CAR TO A MECHANIC TO HAVE IT LOOKED AT. I HAVE ALSO BEEN RESEARCHING OTHER COMPLAINTS ABOUT THE CAR, AND TO MY HORROR, I AM EXPERIENCING MUCH OF THE SAME AS OTHER CONSUMERS. HOW CAN SO MANY COMPLAINTS BE ISSUED ABOUT THE SAME VEHICLE AND GENERAL MOTORS NOT FIXING THE PROBLEMS?? *TR
Nov 27, 2007
RE 2002 CHEVY TAHOE TRANSMISSION PROBLEMS: UP UNTIL THE 34,000 MILE RANGE THE VEHICLE DID JUST THAT, RUN FLAWLESSLY. HOWEVER, AT 34,000 MILES (NOVEMBER OF 2004) THE TRANSMISSION WENT OUT. MY WIFE WAS DRIVING TO WORK AND NEEDED TO ACCELERATE TO MERGE ONTO THE FREEWAY AND INSTANTLY THE TRANSMISSION BEGAN TO WHINE AND STOPPED OPERATING WHICH PLACED HER INTO THE PATH OF A LARGE TRUCK BEARING DOWN ON HER RATHER QUICKLY. THANKFULLY SHE WAS ABLE TO GLIDE OUT OF THE PATH OF THE TRUCK TO THE SIDE OF THE ROAD. WE HAD THE TAHOE TOWED BACK TO OUR DEALERSHIP AND WE DETERMINED THAT THE TRANSMISSION "SUN SHELL" HAD FAILED AND WOULD BE REPLACED. OUR DEALER ASSURED US THAT THIS WOULD SOLVE THE PROBLEM, BECAUSE THE NEW PARTS WERE DESIGNED TO PREVENT THIS FROM OCCURRING IN THE FUTURE. OUR DEALER FURTHER STATED THAT THEY HAVE BEEN REPAIRING A LARGE NUMBER OF VEHICLES WITH THESE FAILURES. OUR TAHOE WENT OFF OF IT'S NEW CAR WARRANTY ON MILEAGE NOT NUMBER OF MONTHS SOMETIME IN APRIL OF 2005 (36 MONTHS WOULD HAVE ENDED THIS AUGUST). JUST THIS PAST MONDAY (SEPTEMBER 19, 2005) MY WIFE WAS AGAIN ON HER WAY TO WORK WHEN AGAIN THE TRANSMISSION FAILED IN OUR 2002 TAHOE. THE MILEAGE WAS APPROX: 41,000 ( TOTAL PERIOD OF MILES AND THE LENGTH OF TIME FROM THE PREVIOUS FAILURE WAS APPROX: 7 MONTHS). THE CIRCUMSTANCES WERE THE SAME, SHE WAS ACCELERATING TO MERGE ONTO THE FREEWAY AND AGAIN THE TRANSMISSION BEGAN TO WHINE AND SLIP. THIS TIME SHE WAS ABLE TO CONTINUE DRIVING TO THE SIDE OF THE ROAD AND RELATIVE SAFETY. WE HAD THE VEHICLE TOWED BACK TO OUR DEALERSHIP AND AGAIN THE DEALER ADVISED THAT THE "SUN SHELL" HAD FAILED. I WENT TO PICK UP THE CAR ON FRIDAY SEPTEMBER 23, 2005 AND WHILE I WAS AT THE DEALERSHIP THE MECHANIC SHOWED ME THE DAMAGED PART AND A BENCH THAT CONTAINED SEVERAL DAMAGED "SUN SHELL". IT OBVIOUSLY DOES NOT TAKE MUCH EFFORT TO REALIZE THAT THERE IS A DESIGN FLAW WITH THIS PARTICULAR TRANSMISSION AND SPECIFICALLY THIS PART. *JB
Sep 28, 2005
WHILE STOPPING ON AN INCLINE, AND WITHOUT ANY INDICATION, VEHICLE WILL ROLL BACKWARDS. DEALER AND MANUFACTURER HAVE BEEN CONTACTED.*AK. VEHICLE ROLLS WHILE IN DRIVE. THE SERVICE DEPARTMENT INFORMED CONSUMER THAT ALL VEHICLES DO THAT. *JG
Jun 10, 2002
FUEL/PROPULSION SYSTEM
3 complaints
My car has the engine 3.1 L automatic. On January 4, I was going to go run errands so I went out to my car and cranked it to start the engine but instead, I heard a loud explosion, causing the front tires of the car to go up in the air and then land back on the ground. Smoke started coming out from the hood and a fire almost got started. I was scared to half to death causing me to almost have a heart attack. Morning inspection, I found that the intake manifold had exploded on the car and pieces of it were all over the engine. I feel that the pressure regulator may have been the culprit, but the plastic upper intake just literally blew up. Nobody was injured neighbors came out to see what the explosion had been, the window on my windshield cracked and major damage has been done to the Plenum. I have pictures but I’ve been unable to upload them but they are available. If you need them I went to Mission Chevrolet where I purchased the car but was referred to contact you in general. no recalls sent over this issue, but have I been driving when the explosion occurred it may have caused fatalities to myself, and perhaps other drivers on the freeway.
Jan 07, 2024
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHILE DRIVING 2 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO ACCELERATE. THE CONTACT OBSERVED FLAMES UNDER THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE FIRE DEPARTMENT STATED THAT THE FIRE OCCURRED DUE TO A FUEL LEAK. PRIOR TO THE FIRE, THERE WERE NO LEAKS PRESENT. THE CONTACT ALSO STATED THAT THE FIRE OCCURRED AFTER THE VEHICLE WAS FUELED. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT A CASE MANAGER WOULD BE ASSIGNED TO THE CASE. THE FAILURE MILEAGE WAS APPROXIMATELY 32,000.
Jun 27, 2017
I WAS DRIVING AND MY GAS NEEDLE STARTED GOING UP AND DOWN. NOW IT DON'T WORK . IF I PUT $5 OF GAS IN IT GO TO FULL. *TR
Dec 11, 2012
UNKNOWN OR OTHER
3 complaints
RECALL NO.14V400
Nov 05, 2017
I TOOK MY VEHICLE TO HAVE SERVICE DONE ON A RECALL INVOLVING POTENTIAL UNDER HOOD FIRE TO REPLACE VALVE COVERS. THE OIL WAS/IS LEAKING ONTO THE MANIFOLD AND CAUSING THE CAR TO SMOKE. I BARELY DRIVE THIS CAR AND IT IS STILL LEAKING OIL ONTO THE MANIFOLD AND SMOKING. NOW THE DEALERSHIP WILL NOT FIX WHAT THEY SUPPOSEDLY FIXED.
May 16, 2017
I RECENTLY PURCHASED A USED 2002 CHEVY MONTE CARLO. HOWEVER I HAVE BEEN HAVING INTERMITTENT PROBLEMS WITH THE VEHICLE NOT STARTING.IT HAS HAD THE RECALLED IGNITION SWITCH REPLACED BUT EVERY ONCE IN A WHILE THE VEHICLE STILL DOESN'T START. I HAVE DONE SOME INVESTIGATING ON THE WEB AND DISCOVERED IT IS A VERY COMMON PROBLEM OF MANY GENERAL MOTORS MAKES BETWEEN THE 1999-2004 MODAL YEARS.THE VEHICLES VATS SYSTEM (VEHICLE ANTI THEFT SYSTEM)WILL NOT ALLOW THE VEHICLE TO START.WHEN THE VEHICLE DOESN'T START I HAVE TO WAIT 10MINUTES AND LOW AND BEHOLD IT WILL START.THIS IS A VERY COMMON PROBLEM THAT IS NOT ONLY AGGRAVATING BUT COULD BE POTENTIALLY DANGEROUS IF THE VEHICLE NEEDS TO BE MOVED IN AN EMERGENCY SITUATION.PLEASE MAKE GM RECALL THESE VEHICLES! SINCERELY [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Jun 20, 2015
STEERING,SERVICE BRAKES, HYDRAULIC
3 complaints
ABS AND TAC OFF LIGHT COME ON STAY ON AND SERVICE TRACTION SYSTEM LIGHT COMES ON TOOK TO SHOP IF DIDN'T FIX (MEANING I HAVE NO ANTILOCK BRAKES AND THEY THING ITS THE ABS MOTOR PUMP THINK) I WONT BE ABLE TO GET A INSPECTION STICKER AND THEY SAID IT WILL COST 1600 TO FIX AND WENT ON WEB AND SEEN MANY HUNDREDS OF 2002 MONTE OWNERS ARE HAVING THE SAME PROBLEM. *TR
Jul 02, 2008
2002 MONTE CARLO : AT 29,000 MILES NEEDS ALL FRONT AND REAR BRAKE ROTORS RESURFACED DUE TO WARPING AND NEW BRAKE PADS. THIS WAS DESCRIBED TO US AS NORMAL AND NOT COVERED UNDER ANY WARRANTIES. VEHICLE IS DRIVEN MAJORITY OF TIME ON THE INTERSTATE HIGHWAY WHERE BRAKES ARE NOT NEEDED MUCH. IN ADDITION, WHEN TURNING A NOISE WAS HEARD/FELT IN STEERING WHEEL. G.M. DEALER SERVICE CENTER HAD TO REPLACE INNER STEERING SHAFT IN STEERING COLUMN? (THEIR DESCRIPTION) THIS WAS REPAIR UNDER WARRANTY. *LA
Nov 20, 2003
AT DRIVING THE SPEED OF 30 MILES PER HOUR, GOING AROUND A BEND, THERE WAS A POPPING NOISE, I THEN LOST CONTROL OF THE STEERING AND HAD NO BRAKES. TRYING TO STEER THE CAR LEFT AROUND THE BEND THE CAR PROCEEDED TO GO STRAIGHT. CAUSING THE CAR TO GO UP THE DRIVEWAY APRON THROUGH A YARD LODGING THE CAR INTO A SHRUB ,STOPPING 5 INCHES FROM GOING INTO A GARGE. I HAD THE CAR TOWED TO METRO CHEVROLET, WAS CONTACTED BY DEALER SAYING IT SOUNDED LIKE A MECHANICAL ERROR. AGAIN CONTACTED BY THE SERVICE DEPARTMENT, THE NEXT DAY SAYING THE CAR WAS DRIVEN OVER A CURB, OR HIT SOMETHING. I EXPLAINED THE CAR WENT THROUGH THE DRIVEWAY APRON, DID NOT HIT CURB, AND RESTING ON A SHRUB WILL NOT CAUSE THE DAMAGE THAT IT SUBSTAINED. DEALER REFUSED TO TAKE RESPONIBILITY. I PROCEEDED TO TAKE PITCURES OF THE SCEEN OF THE ACCIDENT, SHOWING THE PATH OF THE CAR. THE DRIVER SIDE WENT OVER THE CURB, THE PASSENGER SIDE WENT OVER THE APRON OF THE DRIVE. ALL THE DAMAGE WAS DONE TO THE PASSENGER SIDE OF THE CAR. I TRY TO EXPLAIN TO THEM THAT SOMETHING BROKE BEFORE CONTACT WAS MADE WITH THE CURB. I AM REPORTING THIS PROBLEM FOR THE SAFETY OF MY FAMILY, AND ANYONE ELSE WHO MAY HAVE THE SAME PROBLEM BEFORE IT GETS TO THE POINT OF AN ACCIDENT FOR SOMEONE ELSE. AT THIS TIME MY INSURANCE IS PAYING FOR THE REPAIRS, I AM TRYING TO GET THE DEALERSHIP TO HONOR THE CLAIM FOR THE MALFUNCTION. *AK
Feb 06, 2002
SEAT BELTS
3 complaints
PROBLEMS WITH SEAT BELT EQUIPMENT LOCKING TIGHT WHETHER ENGINE IS ON OR OFF. *MR THE SEAT BELT TIGHTENED TO THE POINT THAT IT COULD NOT BE USED. THE CONSUMER WAS UNABLE TO WEAR THE SEAT BELT BECAUSE OF THIS PROBLEM. THIS PROBLEM OCCURRED WHETHER THE VEHICLE OFF OR ON. THE DEALER WAS NOTIFIED NUMEROUS TIMES. THE DEALER WAS PUZZLED AS TO WHY THE BELT WAS LOCKING AND THE FACT THAT THEY COULD NOT GET IT UNLOCKED. THE DEALER NOTIFIED THE MANUFACTURER. THE MANUFACTURER REPLACED THE SEAT BELT FOUR TIMES BUT THE PROBLEM STILL EXIST. *TS *NLM
Nov 05, 2003
CONSUMER STATES FRONTAL SEAT BELT WEBBING IS LOCKING IN PLACE, CONSUMER WAS UNABLE TO LOCK SEAT BELT. *AK
Jun 30, 2003
THE SEAT BELT RUBBED ACROSS THE DRIVERS NECK. THE CONSUMER IS CONCERNED THAT IF INVOLVED IN ACCIDENT IF THERE WOULD BE SEVERE DAMAGE TO HER NECK. THE DEALER WAS NOTIFIED. *NLM *TT
Apr 15, 2003
ENGINE,FUEL/PROPULSION SYSTEM
2 complaints
THE CAR'S FUEL GAGE STOPPED WORKING. THE CAR WOULDN'T TURN OVER WHEN I STARTED IT SO I GOT A NEW BATTERY SINCE IT SAID MY OLD ONE WAS BAD, BUT IT'S STILL NOT WORKING. THE SECURITY LIGHT IS ON AND I DON'T UNDERSTAND WHY AND IF THIS IS AFFECTING IT FROM TURNING ON
May 11, 2019
WENT TO START CAR ONE DAY. TURNED KEY AND HEARD LOUD POP. RUSHED TO LIFT GOOD AND TOP OF MOTOR ON FIRE. LUCKILY HAD EXTINGUISHER RIGHT INSIDE GARAGE DOOR AND IMMEDIATELY EXTINGUISHED. PLASTIC INTAKE COVER WAS BLOWN APART IN MULTIPLE PIECES. AFTER SEARCHING ON THE INTERNET I FOUND THERE HAVE BEEN MANY OF THIS SAME INCIDENT, SOMEWHERE CLAIMING THAT IT COMES FROM A FAULTY FUEL SHIFT OF VALVE OR SOMETHING. IF YOU NOTICE WITH LOW MILES, THIS CAR IS BARELY DRIVEN AND ALWAYS BABIED. *TR
Sep 13, 2015
SERVICE BRAKES
2 complaints
THE BRAKE LINES ARE RUSTED OUT CAR ONLY HAS 55,000 MILES IT IS SITTING OUTSIDE BUT ON BLACKTOP IN OUR DRIVE WAY. WE WENT TO USE IT AND THE DASH LIT LIKE MAD CHECKED BRAKE FLUID IT WAS LOW DROVE IT AND ALMOST DID,NT MAKE IT HOME WITH BRAKES.
Mar 11, 2019
HELLO I WAS TOLD I COULD COMPLAIN TO YOU AND POSSIBLY GET REFUNDED. MY CAR CURRENTLY HAS ABOUT 76,900 MILES ON IT. MY BRAKE LINE RUSTED OUT ON ME, AND I HAD $700 OF WORK DONE ON MY BRAKES, AT MONROE IN LOWELL, MA, ON CHELMSFORD ST. (RT. 110). I WAS TOLD I COULD COMPLAIN ABOUT MY ENTIRE BRAKES RUSTING OUT HERE. THANKS FOR YOUR TIME...UPDATED 07/15/14 *BF UPDATED 3/23/2015 *JS
Jul 08, 2014
FUEL SYSTEM, GASOLINE,ENGINE
2 complaints
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, A STRONG BURNING FUEL ODOR WAS PRESENT INSIDE AND OUTSIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRONT VALVE COVER GASKET NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 193,000.
Apr 13, 2016
WENT OUT TO START CAR. TURNED ON KEY, SET RADIO. THEN TURNED KEY TO START ENGINE WITH A RESULTING LOUD EXPLOSION FROM UNDER HOOD. IN HURRY TO GET UP HOOD AND EXTINGUISH FIRE EXPERIENCED BURNS ON HANDS FROM LIFTING HOOD AND A FUEL LINE THAT WAS SQUIRTING FUEL/FLAMES. FIRE EXTINGUISHER EXTINGUISHED FLAMES. UPPER INTAKE MANIFOLD IS BLOW APART WITH MULTIPLE SENSORS DESTROYED. THANK GOD THIS HAPPENED AT HOME WITH AN EXTINGUISHER HANDY AND NOT DRIVING DOWN THE ROAD WITH NO TIME TO SLOW DOWN. *TR
Jan 31, 2014
VEHICLE SPEED CONTROL
2 complaints
I WAS DRIVING DOWN A BUSY STREET AT APPROXIMATELY 25 MILES PER HOUR AND MY CAR ACCELERATED ON ITS OWN. I HAD TO STEP ON MY BRAKES TO PREVENT FROM REAR ENDING THE VEHICLE IN FRONT OF ME. ATTENTION WHEN I DRIVE. HOWEVER, LESS THAN ONE WEEK LATER, I NOTICED THAT MY CRUISE CONTROL LIGHT WAS ON AND I HAD NOT TOUCHED THE BUTTON TO ACTIVATE CRUISE CONTROL AT ALL. I NEVER USE THIS FEATURE AND COULDN'T UNDERSTAND HOW THIS OCCURRED. I THEN BEGIN TO NOTICE THAT THE CRUISE CONTROL SIGN WOULD ACTIVATE ITSELF AND MY I WAS NO LONGER DRIVING AT THE SPEED THAT I THOUGHT I WAS. I DO NEED TO BACK UP AND STATE THAT I HAD A BIG PROBLEM WITH MY ABS LIGHT GOING ON AND OFF AND HAD TAKEN MY CAR TO MARTIN CHEVROLET TO HAVE THIS PROBLEM REPAIRED. AFTER APPROXIMATELY 4-5 VISITS OF THE SAME PROBLEM AND OUT OF POCKET HUNDREDS OF DOLLARS, THE SERVICE TECHNICIAN FOUND THE PROBLEM AND FIXED IT AT THE TUNE OF $200. I DO COMMEND HIM FOR DIGGING DEEP TO FIND OUT WHAT THE PROBLEM WAS AND HE NEVER GAVE UP TRYING TO FIND A SOLUTION. THE LAST ITEM I WOULD LIKE TO REPORT IS THE ISSUE OF ME BEING SHOCKED WITH SMALL JOLTS OF WHAT I CAN ONLY DESCRIBE AS SMALL ELECTRIC SHOCKS WHEN I WOULD OPEN MY CAR DOOR. THIS DATES BACK TO THE FIRST YEAR THAT I PURCHASED MY BRAND NEW CAR. *TR
Nov 10, 2014
CRUISE CONTROL CANCELS IT'S SELF AT LOW SPEED. VECH UNDER WARR WHEN PROBLEM STARTED. VECH NOT COVERED UNDER LEMON LAW, SO DEALER AND GM REPS ARE IGNORING PROBLEM. MUST SAY DEALER DID TRY TO REPAIR. HAVE NEARLY BEEN REAR-ENDED SEVERAL TIMES AS CRUISE KICKED OUT AND WE WERE SLOWING AND DIDN'T REALIZE IT.*AK
Nov 27, 2004
FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM
2 complaints
3 NEW FUEL PUMP RAILS INSTALLED FROM RECALL ( GAS GAUGE DOES NOT WORK). THE PROBLEM STILL OCCURS, THE GAUGE WORKS FOR A SMALL AMOUNT OF TIME AFTER NEW FUEL RAIL IS INSTALLED, THEN FAILS, LEAVING NO WAY TO CHECK THE AMOUNT OF FUEL LEFT IN THE TANK. *TR
Sep 23, 2010
TL *- THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. ON FEBRUARY 3, 2007 THE CONTACT STARTED THE VEHICLE, THEN TURNED IT OFF QUICKLY AFTER REALIZING SHE HAD FORGOTTEN SOMETHING IN HER HOME. THE CONTACT WENT BACK INSIDE THE HOME, THEN RETURNED TO THE VEHICLE. THE CONTACT STARTED THE VEHICLE A SECOND TIME AND HEARD AN EXPLOSION COMING FROM UNDER THE VEHICLE LOUD ENOUGH THAT THE NEIGHBORS CAME AND OFFERED ASSISTANCE. WHILE INSIDE THE VEHICLE THE CONTACT SMELLED SMOKE. THE CONTACT'S HUSBAND OPENED THE HOOD AND WITNESSED A FIRE COMING FROM THE ENGINE. THE CONTACT'S HUSBAND USED A FIRE EXTINGUISHER TO PUT OUT THE FIRE. THE VEHICLE WAS TRANSPORTED TO THE RIZZA CHEVROLET 8200 SOUTH HARLEM AVE, BRIDGEVIEW IL 60455, TEL 708-594-9090 FOR SERVICE. THE CONTACT FILED A COMPLAINT WITH GMC #71-478219613, AND WAS TOLD TO WAIT 48 HOURS FOR AN AGENT TO BE ASSIGNED TO THE CASE. THE CONTACT NOTED THAT THERE WAS A RECALL ON THE 2000 MONTE CARLO MODELS FOR SIMILAR PROBLEMS, AND THIS VEHICLE SHOULD BE INCLUDED IN THE RECALL. *AK THE CONSUMER STATED THE FAILURE MAYBE RELATED TO RECALL 04V0900000 UPDATED 02/27/07. *JB
Feb 05, 2007
FUEL SYSTEM, GASOLINE
2 complaints
GAS GAUGE ALL OF A SUDDEN STOPPED WORKING AND I RAN OUT OF GAS! *TR
Sep 07, 2010
MY 2002 CHEVY MONTECARLO SS THE GAS GAUGE IS VERY ERRATIC IT SHOWS YOU HAVING A FULL TANK OF A GAS WHEN YOU DON'T IT BOUNCES BACK AND FORTH LIKE THIS NO MATTER IF IT'S FULL OR NOT VERY FRUSTRATING TO KNOW WHEN TO FILL UP... *TR
Aug 28, 2010
TIRES
2 complaints
I PURCHASED TWO CLASSIC P225/60R16 TIRES DESIGN # 8938N ABOUT 2 OR 3 YEARS AGO. THEY STILL ARE LIKE NEW. THEY BOTH ARE STARTING TO HAVE CRACKS IN THE RUBBER AROUND THE RIM. LOOKS LIKE THEY ARE DRY ROTTING. THEY WERE PLACED ON THE REAR OF THE VEHICLE. *TR
Mar 03, 2010
2002 CHEVROLET MONTE CARLO HAS PROBLEMS WITH ONE FAULTY GOOD YEAR TIRE.*MR *NM
Apr 06, 2005
STEERING,ENGINE AND ENGINE COOLING
2 complaints
TL*THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT HEARD A KNOCKING NOISE IN THE STEERING COLUMN EVERYTIME HE TURNED THE WHEEL. THE DEALER WAS ABLE TO DUPLICATE THE FAILURE, BUT COULD NOT DETERMINE THE CAUSE. THE CONTACT WAS INFORMED THAT THE ONLY WAY IT COULD BE REPAIRED WAS BY TAKING THE STEERING COLUMN APART FOR INSPECTION. THE VEHICLE WAS OUT OF WARRANTY; THEREFORE, THE REPAIRS MAY HAVE TO BE MADE AT THE CONTACT'S EXPENSE. HE RECEIVED A RECALL NOTICE FOR THE SPARK PLUGS AND NOW AN OIL LEAK IS PRESENT. THE CONTACT WILL HAVE THE RECALL REPAIR PERFORMED. THE NHTSA CAMPAIGN ID NUMBER WAS UNKNOWN. THE FAILURE MILEAGE WAS 40,000 AND CURRENT MILEAGE WAS 74,000. UPDATED 07/10/09. *LJ UPDATED 07/10/09.*JB
Jun 18, 2009
I OWN A 2002 CHEVROLET MONTE CARLO 53,000 MILES ON IT WITH INTERMEDIATE SHAFT PROBLEMS AND INTAKE MANIFOLD GASKET PROBLEMS. BOTH ARE APPARENTLY COMMON ON THIS MAKE AND MODEL. CHEVROLET SHOULD MAKE THESE REPAIRS. THE STEERING CAN BE AFFECTED, WHICH IS A HAZARD AND THE GASKET COULD CAUSE ENGINE FREEZE UP WHILE DRIVING, ALSO A HAZARD. *JB
Oct 23, 2007
SEATS
2 complaints
TL*- THE CONTACT STATED THAT WHILE DRIVING THE 2002 CHEVROLET MONTE CARLO SS COUPE AT 40 MPH, SHE TURNED THE SEAT WARMER ON AND THE SEAT GOT HOTTER THAN USUAL VERY QUICKLY. THE CONTACT TURNED THE SEAT WARMER OFF, THEN PULLED TO THE SIDE OF THE ROAD, AND NOTICED A BLACK MELTED SPOT ON THE LOWER BACK OF THE DRIVER'S SEAT. THE VEHICLE WAS THEN DRIVEN HOME. *AK THE CONSUMER STATED SHE HAD A WIRE REPLACED ON THE SEATS IN THE PAST. UPDATED 03/07/07. *JB
Feb 01, 2007
FRONT PASSENGER'S SEAT HEATER WILL NOT SHUT OFF, EVEN IF VEHICLE IS NOT RUNNING. CONSOLE MODULE WAS REPLACED BY DEALERSHIP, BUT HEATER ENGAGED AGAIN. THIS TIME THE SYSTEM FAILED, RESULTING IN AN INTERIOR FIRE.*AK *JB
Aug 26, 2002
STEERING,EQUIPMENT
2 complaints
POP IN STEERING AND CLUNK WHEN TURNING AT LOW SPEED. DEALERSHIP HAS REPLACED STEERING COLUMN, STEERING BOX, FRONT END AND ROTORS. HAVE SOLD THE VEHICLE TO INSURE THE SAFETY OF OUR FAMILY. *AK
Sep 24, 2004
2002 MONTE CARLO SS WITH STEERING SAFETY PROBLEMS STEERING COLUMN REPLACED FRONT END REPLACED STILL UNSAFE AND IN SHOP. RECALL CENTER SHOWS NO RECALLS FOR STEERING COLUMN DEALER SAYS THERE IS AND THERE HAVE BEEN REPORTS OF CRACKED FRAMES BUT THESE ARE JUST WHAT THEY CALLED "TECH BULLETINS FROM OTHER DEALER" THERE WAS ALSO A RECALL ON A COOLANT PROBLEM NOT LISTED. 1-160465811 CHEVY COMPLAINT NUMBER. *NLM
Dec 03, 2003
ELECTRICAL SYSTEM,AIR BAGS
2 complaints
THE INSTRUMENT PANEL HAD BEEN LIGHTING UP CERTAIN COMPONENTS INTERMITTENTLY. WHILE DRIVING, THE PASSENGER AND DRIVERS SIDE AIR BAG DEPLOYED. THE DEALER HAD BEEN CONTACTED. PLEASE DESCRIBE FURTHER. *JB AIR BAGS DEPLOYED TWICE. *LA
May 11, 2004
I OWN A 2002 CHEVY MONTE CARLO. AT THE BEGINNING OF NOVEMBER 2003 THE QUAGES ON THE DASH BOARD (TACHOMETOR, SPEEDOMETOR, ABS LIGHT, AIR BAG LIGHT, CHECK ENGINE LIGHT ECT.) WOULD FLASH ON & OFF AND GUAGES WOULD SWEEP UP AND DOWN. ON NOVEMBER 9TH I STOP TO GET GAS AND SHUT THE CAR OFF. WHEN I GOT BACK IN THE CAR AND TURN IT ON THE PASSANGER SIDE AIR BAG DEPLOYED. ON NOVEMBER 24TH WHILE I WAS DRIVING THE DRIVER AIR BAG DEPLOYED. I TOOK THE CAR BOTH TIME TO THE DEALER AND WAS TOLD BY GM THAT THEY WILL NOT FIX THE AIR BAGS. ABOUT A YEAR AGO I BUMPED A CAR IN FRONT OF ME WHILE STOP IN TRAFFIC AND IT MADE A 1 INCH CRACK IN MY BUMPER THE AIR BAGS DID NOT DEPLOY AT THAT TIME. GM STATES THE ACCIDENT THAT HAPPEN A YEAR AGO IS WHY THE AIR BAGS DEPLOYED IN NOVEMBER. THEY ADVISED ME TO CALL MY INSURANCE COMPANY. I TOOK THE CAR TO THE INSURANCE AND THEY CONFIRM THAT THE AIR BAG DEPLOYMENT WAS NOT CAUSE BY THE ACCIDENT. MY INSURANCE IS WORKING WITH ME TO GET GM TO TAKE RESPONSIBILTY FOR THE DEFECT. THEY ADVISED ME TO ALSO FILE A COMPLAINT WITH YOU.
Dec 30, 2003
SERVICE BRAKES, AIR
2 complaints
I HAVE A 2002 MONTE CARLO SS. WITHOUT WARNING THE ABS LIGHT CAME ON. NOTIFIED DEALER AND THEY SAID WAS OK TO DRIVE UNTIL THEY COULD LOOK AT IT. TURNED OUT TO BE A SENSOR AS THEY THOUGHT. THE PROBLEM WAS FIXED BUT AT SIGNIFICANT COST. GM HAS DESIGNED THE SENSOR SUCH THAT IT IS PART OF THE HUB, SO THE WHOLE THING HAD TO BE REPLACED. INSTEAD OF $200 I HAD TO PAY $775. AT 46000 MILES I WOULD NOT EXPECT THIS. I HAVE HAD OTHER VEHICLES WITH ABS WITH OVER 100000 MILES AND NEVER HAD THE FIRST PROBLEM.*AK
Apr 01, 2004
WHEN VEHICLE BRAKES ARE APPLIED THEY WILL PULSATE. DEALERSHIP REPLACE AND TURNED BRAKE ROTORS. PLEASE PROVIDE MORE DETAILS. TS
Oct 31, 2002
SUSPENSION,SERVICE BRAKES, HYDRAULIC
2 complaints
WHEN THE BRAKES WERE APPLIED, THE FRONT OF THE VEHICLE VIBRATED EXTREMELY HARD. *JB
Mar 25, 2003
WHEN THE BRAKES WERE APPLIED, THE FRONT END OF THE VEHICLE VIBRATED EXTREMELY HARD. *JB
Mar 25, 2003
FUEL SYSTEM, DIESEL
1 complaint
TL* THE CONTACT OWNED 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE VEHICLE WAS SERVICED AT APPLE VALLEY CHEVROLET (650 FOXCROFT AVE, MARTINSBURG, WV 25401) FOR A FUEL CONTROL SENSOR REPLACEMENT. THE VEHICLE WOULD NOT START AFTER IT WAS SERVICED AT THE DEALER THEN CAUGHT ON FIRE WHILE THE CONTACT'S HUSBAND WAS TRYING TO START IT UP. THE CONTACT'S HUSBAND WAS ABLE TO PUT OUT THE FIRE WITH A HOSE. NO POLICE REPORT WAS FILED. THE VEHICLE WAS STILL AT THE CONTACT'S RESIDENCE. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 96,000.
Apr 12, 2021
UNKNOWN OR OTHER,ENGINE,FUEL/PROPULSION SYSTEM
1 complaint
STARTED CAR AND HEARD A LOUD BOOM AND THEN SMOKE UNDER THE HOOD AND INTAKE COVER AND HARNESS ON FIRE
Mar 22, 2020
AIR BAGS,SERVICE BRAKES
1 complaint
ABS LIGHT TRACTION CONTROL LIGHT AND AIR BAG LIGHT ARE CONSTANTLY ON..,SINCE IVE OWNED IT
Aug 16, 2018
VEHICLE SPEED CONTROL,ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES
1 complaint
ABOUT OCTOBER 10TH, 2017 I WAS COMING UP ON A TRAFFIC LIGHT AND WHEN I APPLIED THE BRAKES, THE PEDAL WOULD NOT GO DOWN. I WAS GOING ABOUT 45 MPH BY THE GRACE OF GOD I WAS ABLE TO BLAST THROUGH AN INTERSECTION AND MISS EVERYONE, EVERYTHING!. RATTLED I GUESS I SHUT THE CAR OFF WHEN I REGAINED MY COMPOSER I STARTED THE CAR AND EVERYTHING WAS FINE. I DID NOT WANT TO BELIEVE THIS HAPPENED! I THOUGHT I DID SOMETHING WRONG MAYBE HAD MY FOOT UNDER THE BRAKE PEDAL OR SOMETHING. HAVE BEEN DRIVING THE CAR SINCE 2 WEEKS AGO WAS STRANDED IN A PARKING LOT, WOULD NOT START. HAD THE CAR TOWED HOME, TRIED TO START IT AND STARTED RIGHT UP. NOW SERVICE TRACK LIGHT IS ON AND ANTI LOCK BRAKES IS ON AND SERVICE ENGINE LIGHT IS ON SOMETIME AND THE CRUISE LIGHT IS ON. YESTERDAY WIFE WAS DRIVING THE CAR AND SAME THING NO BRAKES, YOU COULD NOT PUSH THE PEDAL DOWN IT IS AS IF THERE IS SOMETHING UNDER THE PEDAL IT'S THAT SOLID. MY CONCERN FOR MY OWN SAFETY AS WELL AS OTHER MONTE CARLO OWNERS IS MOST IMPORTANT. IF EITHER TIME WE WOULD HAVE BEEN ON A EXPRESSWAY WHERE WE COULD NOT TURN TO A SHOULDER THIS WOULD BE CATASTROPHIC . CALLED THE SERVICE MANAGER WHERE THE CAR WAS PURCHASED, ALSO HARBOR CHEVY IN MICHIGAN CITY, IN AND GATES CHEVY IN SOUTH BEND, INDIANA, ALL SAID THEY HAVE NEVER HEARD OF THIS BEFORE. GOT ON THE INTERNET AND FOUND SIMILAR POSTS IN CAR COMPLAINTS WITHOUT ANY PROBLEM, SEEMS ODD GM DOES NOT KNOW ANYTHING ABOUT THIS. FOR EVERY ONES OWN SAFETY THIS SHOULD BE A REDUNDANT SYSTEM IN OLDER CARS YOU WOULD NOT LOSE ALL BRAKES. COULD UNDERSTAND IF YOU LOST ANTI LOCK PART BUT STILL COULD STOP. THIS HAS TO BE A OVERLOOKED FLAW IN DESIGN AND GM SHOULD BE MADE TO CORRECT THIS BEFORE SOMEONE GETS KILLED. IF SOMEONES BEEN KILLED BY THIS HOW COULD THEY TELL YOU THAT HE LOST HIS BRAKES? THANK YOU MIKE
Nov 19, 2017
AIR BAGS,STRUCTURE
1 complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHILE DRIVING AT APPROXIMATELY 35 MPH AND MAKING A LEFT TURN, THE BRAKE PEDAL WAS DEPRESSED BUT THE FLOORMAT BECAME STUCK UNDER THE PEDAL. THE CONTACT COULD NOT STOP THE VEHICLE. THE CONTACT LOST CONTROL OF THE VEHICLE AND CRASHED INTO A BOULDER. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT IT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 28,000.
Jun 09, 2015
AIR BAGS,ENGINE
1 complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHILE DRIVING 25 MPH, THE CHECK ENGINE LIGHT ILLUMINATED AND HALF OF THE AIR BAG WAS EXPOSED ON THE PASSENGER SIDE WHEN THE VEHICLE WAS PURCHASED. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT WAS REFERRED TO THE MANUFACTURER. THE APPROXIMATE FAILURE MILEAGE WAS 156,000.
Jan 12, 2015
POWER TRAIN,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL
1 complaint
DRIVING DOWN THE HIGHWAY WITH THE CRUISE CONTROL THE SPEEDOMETER STARTED TO BOUNCE UP AND DOWN VERY ERRATICALLY. WHEN THE SPEEDO WOULD START BOUNCING IT WOULD DISENGAGE THE CRUISE CONTROL. AT SOME POINTS IT WOULD BOUNCING UP AND DOWN BUT NOT COME BACK ABOVE 40 OR SO MPH. WHEN IT WOULD DO SO THE TRANSMISSION WOULD DOWN SHIFT AND REV WAY UP THEN THE NEEDLE WOULD COME BACK UP AND THE TYRANNY WOULD SHIFT BACK UP. I HAD THE NEEDLE GO TO 0 AND NOT COME BACK UP AT ALL AND WHEN SAT FOR A SECOND THE TRANSMISSION WOULD KICK COMPLETELY OUT AND I WOULD BE STUCK ON THE ROAD FOR A MINUTE. AFTER SITTING FOR A BIT I COULD MOVE BUT THE NEEDLE STAYED AT 0 AND THE TRANSMISSION ACTED TO BE STUCK IN 1ST. *TR
Dec 16, 2014
ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM
1 complaint
2002 CHEVROLET MONTE CARLO. CONSUMER STATES VEHICLE WILL NOT START WHEN THE WEATHER IS HOT WEATHER, AND SHOULD SUBJECT TO A SAFETY RECALL. *SS
Dec 01, 2014
POWER TRAIN,ELECTRICAL SYSTEM,ENGINE
1 complaint
MY FATHER N LAW, N I WERE GOING TO SEE A FAMILY MEMBER 12MILES AWAY FROM HIS HOME, WHEN WE STOPPED. AT THE CONVENIENCE STORE FOR SNACKS, ETC... WE LITERALLY COULDN'T HAVE BEEN OUT OF CAR 5 MIN, WHEN STORE CLERK YELLS HEY SOMEONE'S (CHEVYS) SMOKING? WE SAW IT WAS HIS N WENT TO INVESTIGATE THE PROBLEM I WENT STRAIGHT TO DRIVER SIDE OF VEHICLE N POPPED THE TRUNK(THINKING IT WASN'T MORE THAN A BLOWN RADIATOR HOSE) LORD N HEAVEN WAS I WRONG, THE ENGINE LOOKED AS IF IT WERE ALL ON FIRE...I IMMEDIATELY PUSHED HOOD DOWN N RAN FOR AN EXTINGUISHER LUCKILY THE STORE HAD A GOOD ONE. THIS RECALL AS THE COUNTRY N STATE N MANUFACTURERS, CALL IT IS SERIOUSLY DEADLY, TO B 100 PERCENT HONEST IT IS FLAT OUT WRONG. SOMETHING THIS DEADLY SHOULD B NOTIFIED TO ALL CURRENT OWNERS, OF THE VEHICLES. I SERIOUSLY DOUBT HE WOULD HAVE EVER PURCHASED IT USED OR NEW IF HE KNEW WHAT COULD HAVE HAPPENED IF MY(KIDS)HIS GRAND, WERE W US. MISTAKES HAPPEN. OWN UP TO THEM! THAT'S WHAT MAKES U WHO U ARE. HOPEFULLY YOU WON'T DAMAGE HIM MORE WITH MAKING THIS A 72YR OLD MAN WHO KNOW HAS TO PAY MORE TIME,$$$, N JUST LIFE FOR A MISTAKE HE DIDN'T COMMIT. *TR
Sep 10, 2014
ELECTRICAL SYSTEM,SERVICE BRAKES
1 complaint
WHILE BACKING OUT OF THE DRIVEWAY THE ABS LITE CAME ON WITH WARNING BELLS ALONG WITH THE SERVICE TRACTION LIGHT AND TRAC TURNED OFF. LATER AS I WAS DRIVING ON FREEWAY WITH THESE LIGHTS ON IT BEGAN TO MAKE A GRINDING NOISE. I PULLED ONTO THE SERVICE ROAD AND THE BRAKES FAILED TO STOP THE CAR SO I BLEW THRU THE STOP SIGN AND PULLED INTO A LOT. I TURNED THE CAR OFF AND LET IT SIT A FEW MINUTES. WHEN I RESTARTED I WAS ABLE TO RETURN HOME WITH ALL THE LIGHTS ON. SINCE THEN THE BRAKES HAVE BEEN SERVICED, THE TIE ROD ENDS REPLACED, A NUMBER OF FAILED REPAIR ATTEMPTS AND $2000 LATER, SAME PROBLEM. AFTER EVERY TRIP TO THE MECHANIC AND 500 PLUS DOLLARS THE PROBLEM COMES BACK IN ABOUT A MONTH. THIS CAR OFTEN WILL NOT START, DEAD AS A DOOR NAIL. BY LEAVING THE KEY IN THE IGNITION, TURNING IT TO ON AND NOT TOUCHING ANYTHING FOR TEN MINUTES, IT WILL RESET AND START RIGHT UP. REPLACING STARTER DOES NOT SOLVE PROBLEM. *TR
Jul 31, 2014
ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES
1 complaint
I WENT TO TURN AND MY SERVICE TRACTION CONTROL AND ABS LIGHTS CAME ON. WHILE TURNING, I LOST POWER TO THE BREAKS AND FELT AND HEARD A GRINDING/WHINING NOISE IN THE BRAKES AND COULD NOT STOP. THE VEHICLE NOW HAS A WHINING NOISE WHEN TURNING WITHOUT BRAKING AT ALL. *TR
Apr 05, 2014
STEERING,SERVICE BRAKES,ENGINE
1 complaint
I WAS DRIVING (WITH MY CHILDREN IN CAR) AND THE CAR JUST SHUT OFF. I HAD NO POWER BRAKES OR POWER STEERING. LUCKILY, ONE CHILD WAS IN DRIVERS ED & KNEW TO PUT CAR IN NEUTRAL & WE COASTED TO A STOP. ONCE I CALMED DOWN, I DROVE MY MONTE SS TO THE DEALER AND DESCRIBED WHAT HAPPENED. THE KEPT CAR FOR A WEEK AND INSISTED THERE WAS NOTHING WRONG! I DRIVE 1-3 HRS FOR WORK DAILY AND I DIDN'T TRUST THE VEHICLE ON INTERSTATE. I PURCHASED ANOTHER VEHICLE 6 DAYS LATER BUT GAVE THIS CAR TO MY CHILD FOR IN TOWN DRIVING. I WAS NEVER THE WISER UNTIL I HEARD ABOUT THE RECALL YESTERDAY & IT'S DESCRIPTION. THE MONTE SHOULD BE INVOLVED IN RECALL TOO. I WAS PREPARING TO PURCHASE A NEW IMPALA BUT NOW I BELIEVE GM IS STILL NOT BEING HONEST ABOUT ALL THE MAKES & MODELS INVOLVED WITH IGNITION PROBLEMS. *TR
Apr 01, 2014
ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM,VISIBILITY/WIPER
1 complaint
I HAVE A 2002 CHEVY MONTE CARLO SS AND I AM HAVING ELECTRICAL ISSUES THE WINDSHIELD WIPERS DON'T ALWAYS FUNCTION PROPERLY NEITHER DO THE TURNING SIGNALS MY SEATS WILL MOVE ON THERE OWN ,THERE IS A TICKING NOISE COMING FROM THE DOORS ONCE KEYS ARE TAKEN OUT OF THE IGNITION ALSO I HAVE A PROBLEM WHEN PUMPING GAS INTO THE CAR THE PUMP KEEPS SHUTTING OFF UNLESS I HOLD IT AT A CERTAIN ANGLE. *TR
Mar 21, 2014
LATCHES/LOCKS/LINKAGES
1 complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THE DRIVER'S DOOR LOCK FAILED AND CAUSED THE DRIVERS DOOR TO REMAIN UNLOCKED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 189,000. THE CURRENT MILEAGE WAS 191,671.
Feb 04, 2014
ELECTRICAL SYSTEM,EXTERIOR LIGHTING,ENGINE
1 complaint
MY 2002 CHEVY MONTE CARLO HAS BEEN EXPERIENCING ELECTRICAL PROBLEMS SINCE I HAVE OWNED IT. THE CRUISE CONTROL COMES ON WITHOUT BEING SELECTED AND THEN THE HEATING/COOLING SYSTEMS GOES OFF AND ON BY ITSELF. THE TURN SIGNAL GOES ON AND OFF. SOMETIMES IT WILL WORK SOMETIMES IT WILL NOT. THE FUEL GAUGE DOES NOT REGISTER CORRECTLY GOES UP AND DOWN SO I AM NEVER SURE WHAT IS IN THE TANK. OCCASIONALLY THE CAR WILL NOT START AT ALL EVEN THOUGH THE LIGHTS WORK, THE RADIO PLAYS, AND EVERYTHING ELSE WILL OPERATE INSIDE THE CAR. I WILL SIT AND WAIT A WHILE. AFTER ABOUT 15-25 MINUTES I WILL TRY TO START IT AND THEN IT WILL START UP. THIS HAS BEEN HAPPENING MORE AND MORE. I HAVE TALKED TO OTHER CHEVY MONTE CARLO OWNER AND THEY HAVE HAD THE SAME PROBLEMS WITH THEIR CAR. *TR
Dec 27, 2013
FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM,ENGINE
1 complaint
I STARTED THE CAR UP AND I HEARD A POP AND SAW A BLUE FLAME. AFTER REPAIRING THE CAR COSTING $3240.74 IT ONCE AGAIN CAUGHT ANOTHER FIRE PLEASE HELP. *TR
Jun 05, 2013
SERVICE BRAKES, HYDRAULIC,TRACTION CONTROL SYSTEM
1 complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHEN THE ATTEMPTING A LEFT TURN, THE TRACTION CONTROL WARNING LIGHT WOULD ILLUMINATE AND THE VEHICLE WOULD STALL. THE CONTACT HAD TO REPLACE THE ABS WIRING FOR THE FRONT DRIVER SIDE WHEEL TO CORRECT THE FAILURE. THE VIN WAS NOT AVAILABLE.THE FAILURE MILEAGE WAS UNKNOWN, BUT THE CURRENT MILEAGE WAS 170,000. UPDATED 04/26/12*LJ
Mar 20, 2012
STEERING,POWER TRAIN,ELECTRICAL SYSTEM,EXTERIOR LIGHTING
1 complaint
ON MY WAY TO WORK ON MY NORMAL ROUTE BEFORE DAWN, DRIVING DOWN A NARROW CURVY RURAL ROAD RIFE WITH DEER, I FLICKED ON MY HIGH BEAMS AS USUAL. ABOUT 5 SECONDS LATER I LOST ALL MY HEADLIGHTS. SOMEHOW SAFELY PULLED OFF ROAD WITHOUT FALLING INTO THE DITCH AND TURNED OFF VEHICLE. AFTER SEVERAL MINUTES OF TURNING LIGHTS ON AND OFF THE FOG LAMPS CAME ON AND I WAS ABLE TO MAKE IT BACK HOME VERY SLOWLY. SPENT $1000 GETTING A CONTROL MODULE REPLACED. HAD TROUBLE WITH TURN SIGNALS QUITTING RANDOMLY FOR 3 YEARS, HAVE TO TURN ON EMERGENCY FLASHERS IN ORDER TO GET THEM TO WORK. ANOTHER $500 WILL FIX THE PROBLEM BUT SINCE THE CAR IS ONLY WORTH $1500 IT DOESN'T SEEM WORTH IT. THIS CAR IS A PIECE OF JUNK - 2 TRANSMISSIONS, NUMEROUS ELECTRICAL PROBLEMS, 5 STEERING SHAFT REPLACEMENTS... *TR
Feb 15, 2010
STRUCTURE,EQUIPMENT
1 complaint
CAR PART RECALLED. GOT NOTICE IN JULY 09. CAR CAUGHT FIRE BECAUSE OF PART IN SEP 09. 2002 MONTE CARLO. I WAS TOLD THAT THE CAR'S WARRANTY HAD RUN OUT! PART WAS JUST RECALLED THIS YEAR. THEY JUST FOUND OUT THAT THE PART IS DEFECTIVE. DENIED CLAIM. 9 MO OLD AND 3 YR OLD IN CAR WHEN IT CAUGHT FIRE ON EXPRESSWAY. *TR
Oct 08, 2009
SERVICE BRAKES, HYDRAULIC,ELECTRICAL SYSTEM
1 complaint
LOSS OF TRACTION CONTROL AND ANTI LOCK BRAKES IN MY CAR. MY VEHICLE HAS ALLOWED THESE SAFETY FEATURES TO QUIT WORKING AND AFTER REPLACING THE PARTS THAT THE DEALER SAID NEEDED TO BE REPLACED, THE VEHICLE'S SYSTEM DOES NOT RECOGNIZE THE NEW SENSOR AND PART, THUS NOT ALLOWING THE TRACTION CONTROL AND ABS TO WORK. AFTER RESEARCHING THIS ON THE INTERNET, IT SEEMS TO BE A VERY COMMON PROBLEM IN GM VEHICLES. *TR
Jul 04, 2009
TRACTION CONTROL SYSTEM
1 complaint
I HAVE HAD THE BRAKES CHECKED AND REPAIRED SEVERAL TIMES FOR THE SAME PROBLEM. THE ABS LIGHT KEEPS COMING ON AND THE TRACKING LIGHT SAYS THE TRACTION IS OFF AND TO SERVICE. THE BRAKES SLIP AND SOMETIMES FAILS TO STOP THE CAR. *TR
Jul 02, 2009
STEERING,ENGINE AND ENGINE COOLING,POWER TRAIN,SERVICE BRAKES, ELECTRIC,UNKNOWN OR OTHER,TRACTION CONTROL SYSTEM
1 complaint
I OWN A LEMON OF A 2002 CHEVROLET MONTE CARLO SS. NOTHING BUT PROBLEMS SINCE I BOUGHT IT LAST YEAR. STEERING COLUMN PROBLEMS, COST $200.00 TO FIX, CATALYTIC CONVERTER REPLACED, COVERED BY WARRANTY THANK GOD. TODAY IT IS IN THE SHOP AGAIN FOR LEAKY GASKET AND WHEEL BEARING/ HUB REPLACEMENT WHICH IS COSTING ANOTHER $500.00. THIS WAS BAD BECAUSE THE ABS BREAKS DIDN'T ALWAYS WORK WHICH WAS SCARY SINCE I WONDERED WHEN THEY WERE GOING TO GIVE OUT TOTALLY AND I WOULD BE IN AN ACCIDENT. THE TRANSMISSION SOLENOID ALSO NEEDED TO BE REPLACED WHICH COST US ANOTHER $700.00. IS THERE ANY HELP FOR US? I WONDER WHAT WILL BE NEXT WITH THIS CAR, IT IS A NICE LOOKING CAR, BUT IT SUCKS MECHANICALLY!! PLEASE HELP! ANY SUGGESTIONS? *TR
Apr 14, 2009
PARKING BRAKE
1 complaint
THE 2002 CHEVROLET TAHOE HAS FAILED INSPECTION BECAUSE OF THE EMERGENCY BRAKE.. IT WAS COMPLETELY USELESS. IT DIDN'T WORK. WHY I DON'T KNOW, BUT THE INSPECTION PLACE STATED THAT THEY HAD FAILED NUMEROUS TAHOES WITH THE SAME PROBLEM. I FELT THAT IT WAS UNSAFE AND CHEVROLET SHOULD RECALL THE FEW THAT HAVE THIS PROBLEM. WHY DID IT HAVE TO BE AN INNOCENT PARTY CONCERNING SEVERAL DEATHS OR THOUSANDS OF PEOPLE REPORTING IT BEFORE IT IS RECALLED. I DIDN''T EVEN USE THE BRAKE HOW COULD IT NOT WORK ANYMORE.
Jun 24, 2007
STEERING,SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE,POWER TRAIN,TIRES
1 complaint
2002 CHEVROLET MONTE CARLO WITH ABS AND SERVICE ENGINE LIGHT PROBLEMS AND CONCERNS**CC THE TRACTION LIGHT ILLUMINATED AS WELL. THE TRANSMISSION WAS REPLACED 2 MONTHS AFTER THE CONSUMER PURCHASED THE VEHICLE, BECAUSE THE VEHICLE WOULDN'T GO INTO 3RD GEAR. THE STEERING SHAFT WAS LUBRICATED. THE CONSUMER WAS INFORMED THAT THE EBCM NEEDED TO BE REPLACED AND WITHOUT THE REPLACEMENT, THE ABS WOULD NOT WORK SO THE TRACTION CONTROL AND ABS LIGHT WOULD REMAIN ON. THE WATER PUMP AND INTAKE GASKET WAS REPLACED DUE THEM LEAKING. THE FUEL INJECTOR WAS REPLACED DUE TO IT BEING STUCK OPEN. THE TIRE PRESSURE MONITORING LIGHT ILLUMINATED, THE DEALER SEALED THE REAR WHEELS. *JB
Feb 06, 2007
SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING,AIR BAGS,SEAT BELTS
1 complaint
DT: THE CONTACT WAS UNDER THE IMPRESSION THAT SHE PURCHASED A BRAND NEW VEHICLE. SHE EXPERIENCED SEVERAL PROBLEMS SINCE THE PURCHASE OF THIS VEHICLE. THE VEHICLE HAS BEEN TAKEN TO THE DEALERSHIP THREE TIMES ,AND NO CORRECTIONS HAVE BEEN MADE. THE DEALER DISCOVERED THE ROTORS WERE BENT, AND BRAKES LEAK FLUID. THE VEHICLE STALLED, AND SHOOK TERRIBLY. THE AIR BAGS WERE FELL OUT OF THE DASHBOARD. THE SEAT BELTS ON THE DRIVER'S SIDE INTERMITTENTLY WORKED. THE DEALERSHIP INSISTED THERE WAS NOTHING WRONG WITH THE VEHICLE. SHE CONTACTED THE ATTORNEY GENERAL'S OFFICE REGARDING THE LEMON LAWS. SHE ATTEMPTED TO GET THE DEALERSHIP TO TAKE THE VEHICLE BACK, BUT THEY WILL NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NO LONGER UNDER WARRANTY EVEN THOUGH IT HAD ONLY 10,000 MILES ON IT AT THIS TIME. *AK
Nov 02, 2005
SERVICE BRAKES, HYDRAULIC,LATCHES/LOCKS/LINKAGES
1 complaint
DT: THE CONTACT STATED WHEN OPENING THE DRIVER'S SIDE DOOR THE DOOR WILL NOT STAY OPEN. THE DOOR WILL CLOSE UNLESS HE HOLDS IT OPEN. THE VEHICLE HAS BEEN TO THE DEALER, AND THEY REPLACED THE DOOR STOP. THE REPLACEMENT OF THE PART DID NOT REPAIR THE PROBLEM. ALSO, THE CONTACT WAS HAVING PROBLEMS WITH THE BRAKES. WHILE PRESSING ON THE BRAKES HE COULD FEEL SOME TYPE MOVEMENT IN THE BRAKE PEDAL. THIS ONLY HAPPENED WHEN BACKING THE VEHICLE OUT OF THE DRIVEWAY. THE DRIVEWAY IS ON A SLOPE POSITION. THE DEALER INDICATED THE BRAKING PROBLEM WAS NORMAL . *AK THE DEALER STATED THE ROTORS WERE OUT OF ROUND. UPDATED 01/25/06. *JB
Oct 24, 2005
SERVICE BRAKES, HYDRAULIC,VISIBILITY
1 complaint
DT: SINCE BUYING THE VEHICLE THE CONSUMER HAD A PROBLEM WITH THE ROTORS. THEY HAVE BEEN REPLACED TWICE. WHILE BRAKING THE ROTORS CAUSED THE STEERING WHEEL TO SHAKE VIOLENTLY. TOOK VEHICLE TO THE DEALER FOR A THIRD TIME YESTERDAY. THE DEALER SAID THIS WAS AN ISSUE WITH THE LAMINATION ON THE ROTORS. THE CONSUMER DID NOT HAVE ROTORS REPLACED BECAUSE HE WAS AFRAID HE WOULD BE CHARGED FOR THE REPAIR AS WELL THE DEALER PLACING THE SAME TYPE OF ROTORS THAT HAVE BEEN RUSTING IN THE PAST. THE MECHANIC NOTED AIR BUBBLES IN THE CASTING IN THE ROTORS WHICH THE CAUSED THE RUSTING. *AK WHEN THE VEHICLE WAS DRIVEN AT SPEEDS OF 60 MPH OR EVEN 30 MPH, THE CONSUMER NOTICED PULSATION IN THE BRAKE PEDAL, HOWEVER, WHEN APPROACHING EXIT RAMPS AND WHEN MORE PRESSURE WAS APPLIED TO THE PEDAL, A MORE SEVERE PULSATION WOULD CAUSE THE STEERING WHEEL TO VIBRATE VIOLENTLY. OTHER PROBLEMS: THE DRIVER'S WINDOW SWITCH WAS INOPERATIVE AND THE FRONT BRAKES WOULD GRIND WHEN STOPPING DUE TO ROTOR PROBLEM. *SC *JB
Jul 08, 2005
STEERING,SERVICE BRAKES, AIR,FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM,LATCHES/LOCKS/LINKAGES,INTERIOR LIGHTING
1 complaint
WE BOUGHT OUR ASTRO VAN IN 2001, IT HAS BEEN IN THE SHOP ABOUT 22 OR 23 TIMES. MOST OF THEM MAJOR THINGS NEEDING TO BE FIXED OR REPLACED.*AK
Apr 26, 2005
SUSPENSION
1 complaint
AT 29K MILES, WHEN TURNING THE STEERING WHEEL CONSUMER DETECTED A SQUEALING SOUND THAT HE THOUGHT COULD BE CAUSED BY THE FRONT TIRES. (NAR) *PH CLOCK SPRING BROKEN. *CB
Apr 23, 2004
FUEL SYSTEM, OTHER
1 complaint
THE DRIVER INFORMATION CENTER-FUEL USED IS ALWAYS OFF AT LEAST 1.5 GALLONS WHEN FILLING THE TANK. THIS IN TURN CAUSES THE MILES PER GALLON TO ALSO BE OFF. ONE DEALER MECHANIC SAID THEY HAVE A PROBLEM WITH THE UNIT. BUT MY DEALER SAYS THIS IS NORMAL. WHEN ON A TRIP, MY BROTHERS TWO CADILLACS BOTH READ CORRECT FUEL USED. THE GM 800 HELP LINE NEVER RETURNS MY CALLS. *LA
Nov 17, 2003
SERVICE BRAKES, HYDRAULIC,SERVICE BRAKES, AIR
1 complaint
CAR PULSATES WHEN BRAKING. I TOOK CAR INTO REPAIR SHOP AND WAS TOLD BEFORE INSPECTION THAT THEY HAD BEEN RECEIVING A LOT OF SERVICE WORK FROM THE BRAKE SYSTEMS ON THE NEWER MONTE CARLOS WITH THE 6TH GENERATION BODY STYLE. UPON INSPECTION, IT WAS DETERMINED AS DISCUSSED PRIOR TO INSPECTION THAT THE FRONT ROTORS WERE WARPED AND THE REAR ROTORS ARE RUST PITTED. THEY ALSO REPORTED THAT THE REAR CALIPER WAS LEAKING.
Sep 29, 2003
SERVICE BRAKES, HYDRAULIC,FUEL SYSTEM, GASOLINE,STRUCTURE,TIRES,EQUIPMENT
1 complaint
THESE ISSUES LISTED BELOW ARE TROUBLES I HAVE HAD WITH MY 2002 MONTE CARLO BOUGHT VEHICLE NEW 4/15/02 AND 21/02, FRONT BUMPER PAINT BEGAN TO PEEL. BUMPER REPAINTED./5/02 REAR SPEAKERS BEGIN TO CRACKLE AND QUIT WORKING. REPLACED./30/03 TOOK VEHICLE TO CHEVROLET GARAGE DUE TO VEHICLE PULSATING WHEN STOPPING AND THE CAR HAVING TROUBLE STARTING. FRONT AND REAR ROTORS FOUND WARPED AND RESURFACED. CARS FUEL PRESSURE REGULATOR FOUND TO BE LEAKING DOWN AND WAS REPLACED. 8/21/03 CAR PULSATING AGAIN WHEN STOPPING. RETURNED VECHICLE TO CHEVY GARAGE. FOUND REAR ROTORS RUSTED AGAIN AND REPLACED REAR ROTORS. WAS TOLD TIRES WERE CUPPING IN REAR. ROTATED TIRES ON 8/22/03 AND FOUND SCORE MARK ON REAR DRIVERS SIDE ROTOR. 8/22/03 RETURNED VEHICLE TO CHEVY GARAGE SHOWED SERVICE MANAGER THE DEFECT AND WAS TOLD THE PART WOULD NOT BE REPLACED AT THIS TIME EEVN THOUGH ROTOR WAS SCORED. S.MGR STATED THIS WAS NORMAL CONDITION DUE TO BRAKE PAD METALLIC LINING. 8/24/03 CONTACTED GM CUSTOMER SERVICE ABOUT ISSUE. ASKED TO HAVE NEW ROTORS AND BRAKES PUT ON VEHICLE. RESPONSE WAS "GM IS AWARE OF ISSUES WITH OUR BRAKES AND ROTORS, BUT IF THERE IS NO DEFECT THE PART WOULD NOT BE REPLACED." I RESTATED ABOUT THE SCORE MARK ON THE NEW ROTOR AND WAS TOLD SORRY NOTHING THEY COULD DO AT THIS POINT. 9/2/03 WHILE OIL WAS BEING CHANGED TWO BOLTS WHERE NOTICED MISSING FROM THE TRANSMISSION PAN. WILL BE SERVICED ON 9/4/03 REPAIR PENDING. 9/3/03 VEHICLE HAVING TROUBLE STARTING AGAIN. ENGINE HESITATES FOR 10-20 SEC. WILL BE ADDRESSED ON 9/4/03 THIS VEHICLE ONLY HAS 24,000 MILES ON IT. I NEED NEW BRAKE PADS AND NEW ROTORS DUE TO DEFECTS IN PARTS. VEHICLE HAS 7YR/100,000 MILE WARRANTY. DO I HAVE A LEMON?
Sep 03, 2003
EXTERIOR LIGHTING,INTERIOR LIGHTING
1 complaint
I TO HAVE A 2002 MONTE CARLO SS,THAT WHEN DRIVING AT NIGHT THE LIGHTS,INSIDE AND OUT, FLICKER ON AND OFF.OTHER CARS COMING AT ME CAN ALSO SEE THIS.*AK
Jul 21, 2003
SERVICE BRAKES, HYDRAULIC,EQUIPMENT
1 complaint
MONTE CARLO SS 2002. CAR UNDER 12000 MILES NEEDED NEW BRAKE PADS, AND ROTORS RESURFACED. PREVIOUSLY HAD MALIBU 2000 THAT WAS BOUGHT BACK BY DEALER AFTER 2 YEARS OF ROTOR AND BRAKE PROBLEMS THAT CAUSED 2 CRASHES. WHEN IS SOMEBODY GOING TO LOOK AT THE DESIGN OF EQUIPMENT IN THESE VEHICLES TO SEE THERE IS A DEFECT. DEALERSHIP EVEN ADMITTED TO FLAW. *NLM
Mar 29, 2003
SERVICE BRAKES, HYDRAULIC,AIR BAGS,VEHICLE SPEED CONTROL
1 complaint
I WAS IN A WRECK LAST MONDAY NIGHT WHILE DRIVING A COMPANY VAN. THE CRUISE CONTROL WHEN YOU SET IT AT A SPEED THEN GO DOWN A HILL IT WOULD GET 15-20 MILES FASTER. ANY HOW THE RIGHT FRONT TIRE WENT DOWN AND I HIT A GUARD RAIL WITH THE FRONT OF THE VAN A FIRE STARTED IMMEDIATELY BY MY LEFT FOOT AND NONE OF THE FRONT AIR BAGS DEPLOYED UNTIL THE FIRE GOT TO THEM. THE VAN ROLLED OVER ONCE AND LANDED ON ITS WHEELS THE DOORS WOULDN'T OPEN I ROLLED DOWN THE PASSENGER SIDE WINDOW AND GOT OUT THAT WAY AND THE ABS BRAKES WOULD LOCK UP WHEN YOU HAVE TO GET ON THEM REAL HARD. DT
Nov 29, 2002
Frequently Asked Questions
How many problems does the 2002 CHEVROLET Monte Carlo have?
The 2002 CHEVROLET Monte Carlo currently has 245 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.
What are the most common problems with 2002 CHEVROLET Monte Carlo?
The most common problems reported for the 2002 CHEVROLET Monte Carlo are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.
Where does this 2002 CHEVROLET Monte Carlo problem data come from?
All problem and complaint data for the 2002 CHEVROLET Monte Carlo comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.
Other Years - CHEVROLET Monte Carlo
2024 Problems
2023 Problems
2022 Problems
2021 Problems
2020 Problems
2019 Problems
2018 Problems
2017 Problems
2016 Problems
2015 Problems
2014 Problems
2013 Problems
2012 Problems
2011 Problems
2010 Problems
2009 Problems
2008 Problems
2007 Problems
2006 Problems
2005 Problems
2004 Problems
2003 Problems
2001 Problems
2000 Problems
1999 Problems
1998 Problems
1997 Problems
1996 Problems
1995 Problems
1994 Problems
1993 Problems
1992 Problems
1991 Problems
1990 Problems
Other CHEVROLET Models
Similar Brands
ST
3,555 models
RS
3,484 models
NC
2,822 models
ND
2,385 models
Z
1,951 models
MOTO
1,583 models
NU
1,189 models
RC
1,122 models