How many problems does the 2001 CHEVROLET Suburban have?

The 2001 CHEVROLET Suburban currently has 577 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2001 CHEVROLET Suburban?

The most common problems reported for the 2001 CHEVROLET Suburban are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2001 CHEVROLET Suburban problem data come from?

All problem and complaint data for the 2001 CHEVROLET Suburban comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.

How do I report problems with my 2001 CHEVROLET Suburban?

You can report safety problems with your 2001 CHEVROLET Suburban directly to NHTSA at SaferCar.gov or call 1-888-327-4236. Your complaint helps identify patterns and may lead to recalls or investigations.

Where can I find my VIN to check problems?

Your 2001 CHEVROLET Suburban VIN is located in 4 places: (1) Dashboard near windshield on driver's side, (2) Driver's door jamb sticker, (3) Engine bay, (4) Vehicle registration and insurance documents.

Is the 2001 CHEVROLET Suburban reliable?

Reliability can be assessed by reviewing the number and severity of owner complaints for the 2001 CHEVROLET Suburban. Check complaints by component, crash reports, and fire incidents above to evaluate potential issues and problem patterns.

2001 CHEVROLET Suburban Problems

SERVICE BRAKES, HYDRAULIC

101 complaints

DRIVING DOWN A HILL ON MY STREET THE BRAKES GAVE WAY. I PUSHED THE PEDAL TO THE FLOOR AND THE VEHICLE DID NOT STOP. I WAS ABLE TO PULL OVER AND STOP THE VEHICLE. UPON INSPECTION, THE SERVICE STATION INDICATED THE REAR BRAKE LINES FAILED DUE TO RUSTING. THE VEHICLE WAS TOWED TO THE DEALER, WHERE THE TWO REAR BRAKE LINES WERE REPLACED AS WELL AS A FROZEN CALIPER. UPDATED 08/27/14

Jun 27, 2014

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 1500. WHILE DRIVING APPROXIMATELY 20 MPH, THE BRAKE PEDAL WAS ENGAGED AND THE VEHICLE FAILED TO REDUCE SPEED. THE VEHICLE UNCONTROLLABLY CRASHED INTO A BUILDING. THERE WAS NO PERSONAL INJURY; HOWEVER THERE WERE EXTERIOR DAMAGES TO THE BUILDING. THE VEHICLE SUSTAINED MINOR DAMAGE. A POLICE REPORT WAS NOT FILED OF THE INCIDENT. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE FOUR BRAKE LINES AND GEAR SHIFTER CABLE WERE REPLACED. ALSO, THE ABS WOULD NEED TO BE REPLACED. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 05V379000 (SERVICE BRAKES, HYDRAULIC: ANTILOCK). THE FAILURE RECURRED AFTER THE REPAIR. THE ABS HAD BEEN REPLACED A TOTAL OF SEVEN TIMES. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 97,000.

Mar 20, 2012

Crash: 1

ABS SYSTEM WAS SERVICED AS PART OF 2006 RECALL CAMPAIGN. SENSORS WERE CLEANED AND RETURNED TO SERVICE. PLEASE NOTE THAT IN 2006 WHEN ISSUE FIRST SURFACED, ONE WEEK PRIOR TO RECALL, CHEVROLET DEALER QUOTED A PRICE OVER $800.00 TO REPLACE HUBS. THEN WHEN RECALL WAS ANNOUNCED, THEY SAID THE HUBS COULD BE CLEANED. IN NOVEMBER 2011 SENSORS FAILED AGAIN AND HUBS (HOUSING SENSORS) WERE REPLACED. THE RECALL CAMPAIGN WAS NOT EFFECTIVE. *TR

Mar 18, 2012

VEHICLE WAS SERVICED PER RECALL BELOW ON 1/26/2006. ABS SENSOR WAS INSPECTED AND CLEANED, BUT NOT REPLACED. DEFECT COVERED IN RECALL IS NOW BEING DISPLAYED BY VEHICLE (BRAKING DISTANCE IS EXTENDED AT LOW SPEED - CAUSED BY ABS SENSOR MALFUNCTION). VEHICLE IS CURRENTLY NOT DRIVEABLE. APPARENTLY THE SOLUTION IN THE RECALL WAS NOT SUFFICIENT TO ADDRESS THE PROBLEM. DEALER AND CHEVROLET REFUSE TO ADDRESS THIS PROBLEM. RECOMMEND THAT THE EFFECTIVENESS OF THE RECALL SOLUTION BE RE-EVALUATED. NHTSA ACTION NUMBER: 05V379000 NHTSA RECALL CAMPAIGN NUMBER: PE05020 MAKE: CHEVROLET MODEL: SUBURBAN MANUFACTURER : GENERAL MOTORS LLC MODEL YEAR : 2001 COMPONENT(S) : SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE. *TR

Feb 28, 2012

THIS CONCERN HAS BEEN OCCURRING FOR OVER A YEAR NOW. THE ABS LIGHT COMES ON AND WHEN YOU APPLY THE BRAKES THERE IS A LOUD NOISE AND THE VEHICLE DOES NOT STOP RIGHT AWAY BUT CONTINUES TO MOVE. ON SEVERAL OCCASIONS I ALMOST HIT THE CAR IN FRONT OF ME. TOOK IT TO THE DEALER AND WAS TOLD THE ABS MODULE IS GOING AND THE PRICE TO FIX IT WAS ABSORBENT. TO ME THIS IS A SAFETY CONCERN THAT SHOULD BE ADDRESSED BY CHEVROLET AND NHTSA. *TR

Jan 24, 2012

+ 96 more complaints for this component

FUEL SYSTEM, GASOLINE

52 complaints

SINCE MY LAST MAJOR REPAIR WHICH WAS JULY 2010 WHEN MY RADIATOR AND TIMING BELT HAD MALFUNCTION, WHICH I PAID $653.34 FOR REPAIRS, THE SURBURBAN BEGAN TO STALL AFTER MY LAST OIL CHANGE AT THE DEALERSHIP WHICH WAS 10/04/2011. THE VEHICLE WOULD STALL EACH TIME THE IGNITION KEY WAS TURNED, THEN IT WOULD STALL COMPLETELY AFTER A COUPLE OF TRIES. NOW, THE 2001 SUBURBAN 1500 VEHICLE OF MINE WOULD HAVE A FUEL LEAKAGE AND THE ENGINE STALLS WITH NO RESTART. I TOLD THE DEALERSHIP AFTER MY OIL CHANGE THIS PROBLEM OCCURRED RIGHT AS WE WERE LEAVING THE DEALERSHIP, BUT MY HUSBAND AND I WERE TOLD IT WAS DUE TO THE RECENT OIL CHANGE. NOW THE PROBLEM STILL EXIST WITH NO RESTART AND THE DEALERSHIP SAID TO BRING IT BACK WITH A $90 FEE TO EXAMINE THE VEHICLE WHICH THEY BELIEVE ITS THE FUEL PUMP. I BELIEVE THIS SHOULD'VE BEEN OBSERVED THE DAY OF THE OIL CHANGE WHEN WE INITIALLY OBSERVE THE PROBLEM. IT SEEMS EACH TIME WE HAVE THE VEHICLE OIL CHANGE A PROBLEM OCCUR THE SAME DAY, INWHICH ITS COSTLY TO US. THIS PROBLEM CONTINUES TO EXIST NOW WITH NO START AND THE DEALERSHIP CHARGES US EACH TIME AFTER THE OIL CHANGE TO DETERMINE WHAT THE PROBLEM IS WHICH AS PREVIOUSLY STATED, OCCURS AFTER EACH TIMELY OIL CHANGE. *TR

Oct 24, 2011

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE VEHICLE WOULD EITHER STALL WHILE DRIVING VARIOUS SPEEDS OR FAIL TO START. AN INDEPENDENT MECHANIC EXAMINED THE VEHICLE AND STATED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 05V155000 (FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 141,229.

Oct 05, 2011

2001 CHEVY SUBURBAN FUEL GAUGE READING EMPTY WHEN IT IS NOT EMPTY. SMELL OF FUEL AND BURNING COMING FROM CAR. FUEL GAUGE FLOATING, SHOEING EMPTY,FULL, HALF FULL. *LN

Jan 16, 2011

TL*THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 2500. FOR SEVERAL DAYS, HE SMELLED FUEL AND AFTER HE ADDED FUEL TO TANK HE WAS RECEIVING AND INACCURATE FUEL LEVEL READING. THE DEALER STATED THAT THERE WERE NO RECALLS RELATED TO THE FAILURE. THE MANUFACTURER STATED THAT THERE WERE NOT ENOUGH COMPLAINTS TO ISSUE A RECALL FOR HIS YEAR, MAKE AND MODEL VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND THE FAILURE MILEAGES WERE 88,000.

Nov 18, 2009

TL*THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE FUEL PUMP HAS FAILED TWICE. THE VEHICLE STALLED AND WAS TOWED TO THE DEALER. THE VEHICLE WAS REPAIRED UNDER WARRANTY AT 35,852 MILES. DURING THE SECOND FAILURE, THE ENGINE LIGHT ILLUMINATED AND THE CONTACT TOOK THE VEHICLE TO THE DEALER. THEY PERFORMED A DIAGNOSTIC AND STATED THAT THE FUEL PUMP WAS FAILING. THE VEHICLE HAS NOT BEEN REPAIRED. THE CONTACT IS WAITING ON AN ESTIMATE FOR THE REPAIR COST. THE FAILURE MILEAGE WAS 35,852 AND CURRENT MILEAGE WAS 123,000. UPDATED 05/08/09 *BF UPDATED 05/12/09.*JB UPDATED 06/09/09.*JB

Apr 21, 2009

+ 47 more complaints for this component

SERVICE BRAKES

51 complaints

The ABS and Brake lights illuminate as per GM recall 05v379000. This occurs each time the vehicle is driven. I purchased this vehicle on 12/6/2023 from Kyle's Kars which is a used car dealership in Slatington, PA. A warranty was not offered due to the age, however I did purchase a warranty from Car Shield. This repair would not fall under the warranty guidelines.

Jan 02, 2024

this vehicle has a non-functioning parking brake. There was a recall in 2004 for 880,000 trucks and suv's. I have taken it to my garage twice but they cannot fix this problem because it is not fixable

Jun 25, 2023

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE DRIVING BEHIND HIS FATHER'S VEHICLE, THEY HAD APPROACHED A STOP AND ATTEMPTED TO DEPRESS THE BRAKE PEDAL. AS HIS FOOT WAS ON THE PEDAL, THE CONTACT COULD HEAR THE ABS MAKING AN ABNORMAL NOISE AS THE BRAKE PEDAL FAILED TO OPERATE AS NEEDED. DUE TO THE FAILURE, THE CONTACT HIT THE BACK OF HIS FATHER'S VEHICLE WITHOUT WARNING. DUE TO THE LOW IMPACT OF THE CRASH, THE AIRBAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED AND NO INJURIES WERE REPORTED. THE MANUFACTURER WAS THEN NOTIFIED OF THE FAILURE AND THEY INFORMED HIM THAT HIS VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V379000(SERVICE BRAKES, HYDRAULIC) AND OFFERED NO FURTHER ASSISTANCE. THE VEHICLE HAD YET TO BE REPAIRED. THE FAILURE MILEAGE WAS 159,000.*DT*JB

Jan 07, 2021

Crash: 1

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THAT THE VEHICLE WAS PUT ON A LIFT AND IT WAS DISCOVERED THAT THE BRAKE LINE WAS CORRODED, CAUSING A LEAK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BRAKE LINES NEEDED TO BE REPLACED. THE CONTACT CALLED THE ED BOZARTH CHEVROLET DEALER (877-721-4901, 3731 SW TOPEKA BLVD, TOPEKA, KS 66609) AND WAS TOLD THAT THERE WAS NO RECALL. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 140,000. *TT CONSUMER STATED BRAKE LINES CORRODED AND WAS LEAKING. UPDATED 12/18/18*JB

Oct 29, 2018

I WAS SLOWING FOR A STOP SIGN WHILE LEAVING A PARKING LOT WHEN THE STEEL REAR BRAKE LINE SPONTANEOUSLY SPLIT AND DUMPED ALL LINE PRESSURE. THE BRAKE PEDAL WENT STRAIGHT TO THE FLOOR, AND I ROLLED RIGHT INTO TRAFFIC BEFORE I WAS ABLE TO PUMP THE PEDAL ENOUGH TIMES TO STOP THE VEHICLE AGAINST A CURB. HAD I NEARED THE STOP SIGN 2 SECONDS EARLIER OR LATER, I WOULD HAVE EITHER BEEN T-BONED BY A BOX TRUCK, OR T-BONED A SMALL SEDAN. I EMPHASIZE THAT THE BRAKE LINES SHOWED NO WARNING SIGNS BEYOND THE TYPICAL SURFACE RUST THAT CAN BE FOUND ON ANY VEHICLE THAT HAS BEEN DRIVEN FOR MORE THAN A FEW WINTERS IN THE "RUST BELT". HOWEVER, THOSE VEHICLES DO NOT HAVE BRAKE LINES SPONTANEOUSLY FAIL AT THE RATE THAT THESE GM TRUCKS DO. THIS TRUCK'S PRIMARY PURPOSE IS TOWING A CAMPING TRAILER FOR VACATIONS WITH MY YOUNG FAMILY, SO THIS COULD HAVE ENDED VERY DIFFERENTLY. I URGE YOU TO TAKE GM TO TASK AND FORCE THEM TO FIX THEIR MISTAKE OF CHEAPING OUT ON BRAKE LINE MATERIALS!

Oct 01, 2018

+ 46 more complaints for this component

PARKING BRAKE

45 complaints

TL*THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 1500. UPON INSPECTION OF THE VEHICLE, THE EMERGENCY BRAKE DID NOT FUNCTION AND THE VEHICLE FAILED INSPECTION. THERE IS AN OPEN AND CLOSED INVESTIGATION REGARDING THIS FAILURE. THE VIN AND INVESTIGATION NUMBER WERE UNKNOWN. THE FAILURE MILEAGE WAS 68,000.

May 02, 2008

I OWN A 2001 CHEVROLET SUBURBAN 1500 2WD 5.3L V8 WITH AUTOMATIC TRANSMISSION. THIS VEHICLE WAS BOUGHT NEW AND FROM DAY ONE, THE EMERGENCY BRAKE HAS BEEN COMPLETELY INEFFECTIVE IN HOLDING THE VEHICLE WHEN APPLIED. A CURSORY CHECK ON THE INTERNET REVEALS THAT THIS IS A WIDESPREAD AND VERY WELL-KNOWN PROBLEM FOR OWNERS OF SIMILAR GM VEHICLES. VISITS TO TWO SEPARATE GM DEALERSHIPS IN DALLAS CONFIRM THAT THE DEALERS KNOW OF THIS AS A WIDESPREAD AND WELL-KNOWN PROBLEM AS WELL. ODDLY, THE NHTSA HAD A CHANCE TO REVIEW THIS VEHICLE SAFETY DEFECT AT THE REQUEST OF THE NORTH CAROLINA CONSUMER COUNCIL BACK IN 2005, YET THE NHTSA DECIDED AT THE TIME THAT THIS DEFECT DID NOT WARRANT A SAFETY RECALL. THE SUMMARY CONCLUDES THAT FOR AUTO-TRANSMISSION-EQUIPPED VEHICLES, THE PRESENCE OF A "PARK PAWL" SERVES AS SUFFICIENT HOLDING POWER FOR THESE VEHICLES AND THEREFORE THE APPEAL FOR A SAFETY RECALL WAS DENIED. THERE IS AT LEAST ONE MAJOR PROBLEM WITH THIS CONCLUSION -- NO STATE IS GOING TO ALLOW A VEHICLE WITHOUT A WORKING PARKING BRAKE TO PASS A STATE SAFETY INSPECTION. I KNOW THIS FIRST HAND, AT LEAST IN TEXAS I DO. IT OF COURSE MAKES NO SENSE FOR THE NHTSA TO HAVE A DIFFERENT STANDARD OF VEHICLE SAFETY THAN THE CONSTITUENT STATES DO. EITHER THIS IS AN ISSUE WORTHY OF A NATIONAL SAFETY RECALL, OR THE LACK OF A WORKING PARKING BRAKE SHOULD NOT SERVE AS A VEHICLE FOR FAILURE OF A STATE SAFETY INSPECTION. *TR

Mar 04, 2008

TL*THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. WHEN THE CONTACT STARTED THE VEHICLE, THE LIGHT THAT INDICATES THE PARKING BRAKE IS ACTIVATED WAS NOT ILLUMINATED. THE GEAR WAS SHIFTED INTO DRIVE AND THE VEHICLE BEGAN TO DRIFT WHILE THE EMERGENCY BRAKE WAS STILL APPLIED. THE CONTACT TURNED OFF THE ENGINE. PRIOR TO THE FAILURE, THE CONTACT HEARD THE SOUND OF METAL COMING FROM THE REAR OF THE VEHICLE WHENEVER THE BRAKES WERE APPLIED. THE PARKING BRAKE WAS REPLACED BY A REPAIR SHOP; HOWEVER, THE FAILURE CONTINUED. THE FAILURE MILEAGE WAS 30,000 AND CURRENT MILEAGE WAS 90,000.

Dec 28, 2007

PARKING BRAKES FAILS TO WORK. TRIED TO ADJUST. DID EVERYTHING SHORT OF REPLACING TO WHOLE THING. I DID NOT WORK FROM DAY ONE. *TR

Nov 06, 2007

EMERGENCY BRAKE WENT OUT FOR NO REASON. WE HAVE NEVER USED EMERGENCY BRAKE SINCE OWNING THE CAR IN 2001. *JB

Sep 11, 2007

+ 40 more complaints for this component

TIRES

35 complaints

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 1500 EQUIPPED WITH FIRESTONE WILDERNESS LETIRES, TIRES SIZE: 265/70R16. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY AT 55 MPH, THE VEHICLE BEGAN TO VIOLENTLY SHAKE AND VIBRATE BEFORE A LOUD BOOMING SOUND WAS HEARD. AFTER STOPPING THE VEHICLE, IT WAS DISCOVERED THAT THE REAR PASSENGER SIDE TIRE HAD EXPERIENCED A BLOWOUT. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE FAILURE MILEAGE WAS 150,000 AND THE TIRE FAILURE MILEAGE WAS 10,000. THE VIN WAS NOT AVAILABLE.

Jul 26, 2016

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN EQUIPPED WITH HERCULES ALL TRAC A/T TIRES, SIZE: 265/70R16 (NA). WHILE DRIVING APPROXIMATELY 70 MPH, THE REAR DRIVER SIDE TIRE BLEW OUT. THE TIRE WAS REPLACED WITH A SPARE TIRE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT TIRE TECHNICIAN WHO REPLACED THE TIRE. THE VIN WAS UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE TIRE FAILURE MILEAGE WAS 5,000 AND THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 205,000.

Aug 17, 2015

HAD NEW WILDCOUNTRY TIRE, PURCHASED FROM LES SCHWAB SEPARATE FROM THE WHEEL OUT TO A DEFECT. TIRE HAD ONLY BEEN ON THE WHEEL APPROXIMATELY 6 HOURS BEFORE THE INCIDENT. LT 26570R16. *TR

Sep 08, 2011

THE SPARE TIRE ASSEMBLY'S STEEL WIRE BROKE WHILE SPARE TIRE WAS STORED UNDER THE TRUCK. THIS OCCURRED WHILE BACKING THE VEHICLE OUT OF THE DRIVEWAY. *TR

Nov 20, 2010

I PURCHASED A SET OF SIGMA STAMPEDE TIRES IN 2-2007. 3 OF THE 4 TIRES PURCHASED HAD SIDE WAL BLOW OUTS. I TOOK THE TIRES TO WHERE I BOUGHT THEM AND THE OWNER SAID IT LOOKED AS THOUGH THERE COULD BE A DEFECT. I CONTACTED TBC CORP. ABOUT THE PROBLEM AND WAS TOLD THAT THIS TIRE HAD BEEN RECALLED BUT THE SET I HAD WAS THE WRONG DOT #. I THEN TOLD THEM 3 OUT OF 4 TIRES THAT HAD NO TREAD DAMAGE THAT BLOW OUT THE SIDE WALL SHOULD BE LOOKED AT I WAS TOLD TO GET MY RECEIPT AND FAX IT TO THEM AND THEY WOULD MAKE AN ADJUSTMENT ON 2 OF THE TIRES THIS WAS DONE 2 WEEKS AGO AND I HAVE NOT HEARD FROM THEM . THE FIRST TIRE BLEW OUT 11-2008, AND I REPLACED IT . THE SECOND ON 4- 2009AND THE THIRD ON 7-12-2009. THEY SAID THAT I WOULD NEED ALL THE BAD TIRES FOR THEM TO LOOK AT , BUT ALL BUT 1 CANNOT BE RECOVERED THEY HAD ME TAKE THE REMAINING TIRE 34 MILES FROM MY HOME TO ONE OF THEIR DISTRIBUTORS TO LOOK AT ,WHEN I WENT THEY WOULD NOT EVEN LOOK AT IT . THIS COMPANY HAS DONE NOTHING BUT GIVE ME A RUN-AROUND WHEN ALL I WANTED WAS TO MAKE THEM AWARE OF A POSSIBLE PROBLEM. THEY WERE THE PNES THAT MENTION AN ADJUSTMENT, AND AFTER DOING WHAT THEY ASKED THEY WILL NOT CONTACT ME BACK. *TR

Aug 18, 2009

+ 30 more complaints for this component

ENGINE AND ENGINE COOLING

34 complaints

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE VEHICLE WOULD SPORADICALLY BECOME HESITANT TO START. THE VEHICLE WOULD ALSO STALL PERIODICALLY WITHOUT WARNING. THE VEHICLE WAS INSPECTED BY THE DEALER AND THE CONTACT WAS ADVISED THAT THE FAILURE WAS CAUSED BY THE CAMSHAFT POSITION SENSOR. THE MANUFACTURER WAS MADE AWARE OF FAILURE AND STATED THAT THE PART HAD BEEN DISCONTINUED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER 07V521000 (ENGINE AND ENGINE COOLING) BUT WAS ADVISED THAT THE VIN WAS NOT INCLUDED IN THE RECALL CAMPAIGN. THE FAILURE MILEAGE WAS 18,000. THE CURRENT MILEAGE WAS 20,177. UPDATED 06/17/13 *BF

Apr 09, 2013

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE DRIVING 15 MPH THE VEHICLE STALLED WITHOUT ANY WARNING. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS UNKNOWN.

Nov 02, 2011

NOTICED NO BOLT HEAD ON DRIVERS SIDE REAR EXHAUST MANIFOLD, WAS NOT SURE IF IT WAS SUPPOSED TO BE THERE. THEN FOUND ANOTHER BOLT HEAD IN SKID GUARD DURING OIL CHANGE, THIS WAS FROM THE FRONT BOLT OF SAME EXHAUST MANIFOLD! THE HEADS BROKE OFF CLEANLY FOR NO VISIBLE REASON. FIXED FRONT BOLT BUT REAR ONE REQUIRES EXHAUST MANIFOLD REMOVAL AT COST OF $400.00. THIS COULD BE VERY DANGEROUS IF MORE BREAK! *TR

Oct 31, 2011

I HAVE A 2001 CHEVY SUBURBAN THAT COMPLETELY STALLED OUT, (SEPT 29,2011) WHEN I WAS GETTING READY TO TRANSPORT MY FOUR YOUNG CHILDREN TO SCHOOL. PLEASE NOTE, THAT I'M IN AN AREA THAT IS NOT ACCESSIBLE BY PUBLIC TRANSPORTATION. THIS MEANS THAT WHEN MY CAR IS DOWN, I'M AT THE MERCY OF FRIENDS AND NEIGHBORS WHICH IS QUITE AN INCONVENIENCE. I HIRED A SERVICE GUY TO DIAGNOSE THE PROBLEM AND HE SAID IT WAS A PROBLEM WITH THE CRANKSHAFT. WHILE ORDERING THE PART, HE WAS NOTIFIED THAT THE PART WAS ON A RECALL LIST. I CHECKED THE WEBSITE NHTSA.GOV TO VERIFY AND THE RECALL #07V521000 DID EXIST. I CONTACTED THE CHEVY DEALER (NASH CHEVROLET) IN SNELLVILLE AND WAS TOLD THAT MY VIN# WAS NOT IN THE BATCH AND IF THEY SERVICED IT, THE COST WOULD BE $2500. I CONTACTED THE MANUFACTURER AND WAS TOLD THAT MY PROBLEM COULD BE ATTRIBUTED TO WEAR AND TEAR. I WOULD LIKE TO KNOW IF THERE IS ANY POSSIBILITY TO GET THE DEALER TO REPAIR MY CAR AND IF IT'S POSSIBLE TO HAVE THE INVESTIGATION REOPENED AND THE SCOPE ADJUSTED TO INCLUDE ALL 2001 SUBURBANS THAT ARE NONCONFORMING. I WOULD LIKE TO ALSO KNOW, HOW DOES GM/CHEVY DETERMINE WHICH CUSTOMERS DESERVE TO BE SAFE ON THE ROAD, AND WHY WEREN'T ALL THEIR QUALIFYING CONSUMERS NOTIFIED. IS GM ABOVE THE LAW? HOW IS IT THAT GM IS NOT ALLOWED TO COMPLY TO THESE FEDERAL LAWS AFTER AN INVESTIGATION HAS BEEN CONDUCTED? DOES GM ONLY RESPOND TO THEIR CUSTOMERS IF THEIR IS DEATH AND DISMEMBERMENT OR IF LITIGATION IS INVOLVED? PLEASE ADVISE. *TR

Oct 03, 2011

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 2500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE SUDDENLY STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE FAILURE OCCURRED THREE DIFFERENT TIMES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTICS, WHERE THE TECHNICIANS STATED THAT THE CRANKSHAFT POSITION SENSOR NEEDED TO BE REPLACED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 07V521000 (ENGINE AND ENGINE COOLING) THAT MAY BE RELATED TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 88,000. UPDATED 11/17/11 *BF UPDATED 11/23/11. *JB

Aug 16, 2011

+ 29 more complaints for this component

POWER TRAIN

28 complaints

I WAS DRIVING ON THE NJ TURNPIKE NEAR EXIT 10, TRAVELLING TO BOSTON. AHEAD, ALL TRAFFIC WAS STOPPED IN BOTH THE INNER AND OUTER SET OF LANES. AS I DECELERATED, I HEARD A NOISE AND THE TRUCK JERKED SLIGHTLY. WHEN I TRIED TO PULL OFF THE ROAD INTO THE SERVICE LANE, I HAD NO TRANSMISSION AND HAD TO DRIFT TO THE SHOULDER. I WAS TOLD THERE WAS A CATASTROPHIC FAILURE OF THE TRANSMISSION AND IT HAD TO BE COMPLETELY REBUILT (UNDER WARRANTY). WHEN THE VEHICLE HAD AROUND 70,000 MILES (ABOUT 2 YEARS AGO, 2013), THE TRANSMISSION FAILED AGAIN AND HAD TO BE COMPLETELY REBUILT AGAIN. PATHETIC. THE VEHICLE CURRENTLY HAS 83,000 MI ON IT.

May 24, 2015

I HAVE A 2001 1500 CHEVY SUBURBAN THAT I PURCHASED BRAND NEW. IT WAS 109,000 MILES ON IT. MY TRANSMISSION WENT OUT WITH NO WARNING AT 50,000 MILES. WE FOUGHT WITH DEALERSHIP AND MANUFACTURER AND HAD THEM REPLACE IT WITH A NEW ONE. WELL GUESS WHAT? I HAVE APPR. 59,000 ON THIS TRANSMISSION AND IT JUST WENT OUT ON US ON OUR THANKSGIVING TRIP. WE WERE 4 HRS. FROM HOME WHEN IT STARTED GOING OUT. WHEN WE WERE 3 HRS. FROM HOME WE LOST 3RD GEAR AND DROVE IN 2ND AT 40 MILES PER HR. STOPPING SEVERAL TIMES ALONG THE WAY TO LET IT COOL DOWN. WE MADE IT 2 HRS FROM HOME AND MADE THE DECISION TO PARK IT SOMEWHERE IT WILL BE SAFE TO LEAVE IT OVERNIGHT. THANK GOD OUR SON WAS FOLLOWING US IN HIS VEHICLE TO GIVE US A RIDE HOME. THE FOLLOWING DAY WE HAD TO RETURN TO TOW IT HOME. I AM BEYOND LIVID. THIS VEHICLE IS ONLY DRIVEN IN TOWN AND THE OCCASIONAL VACATION OR ROAD TRIP. IT HAS A TOW PKG BUT HASN'T BEEN USED TO PULL THINGS. IT HAS ALWAYS BEEN METICULOUSLY MAINTAINED BY MY HUSBAND THAT IS A MECHANIC. THIS VEHICLE HAS NEVER BEEN MISUSED OR ABUSED. SO WHAT IS THE PROBLEM WITH CHEVROLET SUBURBAN'S? WE HAVE HAD ABSOLUTELY NO OTHER ISSUES WITH IT AND HAVE LOVED THIS VEHICLE. I HAVE RESEARCHED AND NOTICED I AM NOT THE ONLY ONE WITH THIS ISSUE.. WHAT IS THE PROBLEM? HOW DOES CHEVROLET PLAN ON HANDLING THIS ISSUE? THREE TRANSMISSIONS IN ONE VEHICLE WITH THAT LOW OF MILEAGE IS RIDICULOUS. CHEVROLET YOU ARE PRODUCING FAULTY PRODUCTS. THERE IS NO EXCUSE FOR 2 TRANSMISSIONS GOING ON A 3RD, IN A VEHICLE WITH THAT LOW OF MILEAGE... THIRD TRANSMISSION, REALLY? I HAVE ALWAYS LOVED AND PROMOTED CHEVROLET, BUT NOT ANY MORE. THE TAXPAYERS BAILED CHEVROLET OUT OF BANKRUPTCY AND YOU STILL SCREW OVER THE CONSUMER. IF ANYONE ELSE HAS HAD ANY ISSUES LIKE THIS PLEASE LET ME KNOW. I AM FURIOUS THAT I HAVE TO HAVE A 3RD, YES 3RD TRANSMISSION IN A VEHICLE WITH UNDER 110,000 MILES ON IT.... *TR

Nov 25, 2012

2001 CHEVY SUBURBAN 1500 LT, 5.7 STALLING PROBLEM. STALLS AT LOW IDLE ROUNDING CORNERS, AND IN PARKING LOTS ENTERING AND EXITING SPACE. RUNS FINE AT NORMAL SPEED. NO STALLING DURING REGULAR HIGHWAY SPEED DRIVING UNLESS SLOWING TO ROUND A CORNER. *TR

Jan 05, 2010

I HAVE A 2001 CHEVY SUBURBAN AND THIS IS THE 5TH. TRANSMISSION I HAVE PUT IN THE VEHICLE. THE TRANSMISSION FIRST FAILED AT 15,339 MILES AND WAS REPAIRED UNDER WARRANTY. AT 50,525 MILES IT FAILED AGAIN AND COST ME $1802.94 TO FIX. AT 62,823 IT FAILED AGAIN AND A CHEVROLET DEALER IN OKLAHOMA REPAIRED IT,FOR $2279.24, AND GAVE IT A ONE YEAR WARRANTY. 11 MONTHS AND 10800 MILES LATER IT FAILED AGAIN. THIS TIME THE CHEVY DEALER IN MISSOURI WANTS $1600 TO REPAIR IT AND SAID THE SAME EXACT PARTS DID NOT FAIL SO THE ONE YEAR WARRANTY DOES NOT APPLY!!!!!!!! THIS VEHICLE IS DRIVEN BY MY WIFE AROUND TOWN. ALL OF A SUDDEN YOU LOOSE POWER. *JB

Oct 15, 2007

TRANSMISSION ON A 2001 CHEVY SUBURBAN WITH 76000 MILES FAILED WHILE ON EXPRESSWAY ALMOST CAUSED AN ACCIDENT. *NM

Dec 07, 2006

+ 23 more complaints for this component

AIR BAGS

22 complaints

WHILE TRAVELLING ON THE HIGHWAY AT APPROXIMATELY 50 MPH, VEHICLE STRUCK AN ADULT DEER - FRONT END SQUARE HIT OFFSET TO PASSENGER SIDE. FRONT PASSENGER LIGHTS, GRILL, RADIATOR SUPPORTS, BUMPER, SIDE FENDER, AND HOOD ALL SEVERELY DAMAGED. AIRBAGS DID NOT DEPLOY. DAMAGE TO THE VEHICLE ENDED UP AT $4,386.

Sep 24, 2015

Crash: 1

MY SON WAS DRIVING AND REAR ENDED A MAN GOING APPROXIMATELY 50 MPH. THE FRONT END SUSTAINED A GREAT DEAL OF DAMAGE, INCLUDING, BUT NOT LIMITED TO, THE ENGINE BEING PUSHED BACK SEVERAL INCHES. THE AIR BAGS DID NOT DEPLOY. MY SON SUSTAINED MINOR WHIPLASH TYPE INJURIES TO HIS NECK AND BACK.

Jul 02, 2015

Crash: 1

Injuries: 1

TL* THE CONTACT OWNED A 2001 CHEVROLET SUBURBAN. WHILE DRIVING AT 55 MPH UPHILL, THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE VEHICLE HYDROPLANED. AS A RESULT, THE CONTACT CRASHED INTO THE REAR OF A PICK-UP TRUCK. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THERE WAS ONE INJURY THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED AND TOWED TO AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 270,000.

Jul 02, 2015

Crash: 1

Injuries: 1

ON JANUARY 29, 2014, MY HUSBAND WAS DRIVING MY SUBURBAN TRAVELING ON A SNOW AND ICY ROAD WHEN THE SUBURBAN BEGIN TO SPIN AND WENT DOWN AN EMBANKMENT. HE WAS TRAPPED IN THE VEHICLE BETWEEN THE STEERING WHEEL AND WINDSHIELD. HE WAS WEARING THE SHOULDER AND LAP BELT.THE AIR BAGS DID NOT DEPLOY. TWO OTHER PASSENGERS IN THE VEHICLE HAD ONLY MINOR INJURIES. THE TENNESSEE TRAFFIC REPORT I RECEIVED STATED: AIRBAG AVAILABLE-NO DEPLOYMENT. *TR

Jan 03, 2015

Crash: 1

Injuries: 1

I WAS DRIVING ON MAY 12 FROM FILLMORE CA TO LAX AIRPORT I WAS ON FREEWAY 5 PASSING VALENCIA BY THE EXIT OF FREEWAY 14 WHEN A WHITE BAN HIT THEIR BRAKES I DID THE SAME THING BUT I THINK THE BRAKE OF MY CAR DID WORK PROPERLY AND I LOST CONTROL OF MY CAR SO I WENT TO THE LEFT LINE AND A GREY CIVIC HIT ME ON MY DRIVER SIDE BY THE FRONT TIRE I HAD MY TWO KIDS WITH ME THEY WERE SO SCARE BECAUSE I WAS BLINDING FROM MY HEAD MY AIR BAGS NEVER CAME ON IF YOU HAVE ANY PLEASE CALL [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *JS

May 18, 2014

Crash: 1

Injuries: 5

+ 17 more complaints for this component

STEERING

21 complaints

TL*THE CONTACT OWNS A 2001 CHEVROLET CORVETTE. THE CONTACT STATED THAT HE TOOK THE VEHICLE IN FOR RECALL NHTSA CAMPAIGN ID NUMBER: 04V060000 COMPONENT: STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE. THE VEHICLE WAS SERVICED FOR THIS RECALL IN 2008 AND NOW THE FAILURE HAS RECURRED. THE CONTACT STATED THAT THIS IS A SAFETY ISSUE DUE TO THE FACT THAT THE REMEDY FOR A SAFETY ISSUE FAILED CREATING THE SAME SAFETY CONDITION. THE FAILURE AND CURRENT MILEAGES WERE 27,000. UPDATED 12/22/10. *LJ

Sep 02, 2010

TL*THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. WHILE THE CONTACT WAS DRIVING 40 MPH HE HEARD A RATTLING AND KNOCKING SOUND IN THE STEERING WHEEL. THE VEHICLE HAS NOT BEEN DIAGNOSED OR SERVICED BY THE DEALER FOR THE FAILURE. THE FAILURE MILEAGE WAS 105,000 AND THE CURRENT MILEAGE WAS 111,000.

Mar 10, 2010

CLUNKING FROM FRONT SUSPENSION, GM KNOWS THERE IS A PROBLEM, WHAT HAPPENS IF INTERMEDIATE SHAFT FAILS? *TR

May 07, 2009

WHILE DRIVING THE POWER STEERING FAILED MAKING THE VEHICLE NEARLY IMPOSSIBLE TO STEER. AFTER TOWING IT TO A CHEVY DEALER, THEY INFORMED US THAT THE SHAFT IN THE POWER STEERING PUMP HAD BROKEN. THERE IS A NHTSA RECALL ON GM/CHEVY TRUCKS FOR THIS PROBLEM. GM DOES NOT ACKNOWLEDGE ANY RECALL FOR POWER STEERING PUMPS. *TR

Jun 23, 2008

WHEN MAKING SHARP TURNS AT LOW SPEED POWER STEERING FAILS. THIS HAS HAPPENED AT LEAST 25 TIMES. BROUGHT TRUCK TO MECHANIC AND HE HAS CHECKED BELTS AND FLUIDS AND SAYS HE DOESN'T SEE ANYTHING WRONG WITH THOSE ITEMS. SOMETIMES WHEN I AM DRIVING I FEEL LIKE STEERING IS EXTREMELY LOOSE. *TR

Jun 17, 2008

+ 16 more complaints for this component

SEAT BELTS

20 complaints

THE PASSENGER SIDE SECOND SEAT SEAT BELT WILL NOT RETRACT.

Aug 22, 2018

TL* - THE CONTACT OWNS A 2001 SUBURBAN CHEVROLET. THE CONTACT RECEIVED ASAFETY RECALL 01V159000 CONCERNING SEAT BELTS, RERTRACTOR ON SECOND AND THIRD ROW SEATS. THE DEALER STATED THAT THE SAFETY RECALL DID NOT APPLY TO THE CONTACT'S VEHICLE DUE TO THE VIN. THE CONTACT'S PASSENGER SIDE RETRACTOR DID NOT WORK, AND SHE WOULD LIKE TO HAVE IT REPAIRED UNDER THE SAFETY RECALL. THE DEALER WON'T ACKNOWLEDGE THE SAFETY RECALL EVEN EXISTED

Jan 31, 2007

DT: THE CONTACT STATED THE THIRD ROW PASSENGER SIDE SEAT BELT WAS WRAPPED AROUND THE CHILD'S NECK. THE SEAT BELT HAD TO BE CUT TO FREE THE CHILD. THERE SHOULD BE A WAY TO TURN OFF THE LOCKING FEATURE OF THE SAFETY BELT. *AK

Nov 07, 2005

2001 CHEVROLET SUBURBAN FRONT PASSENGER SEATBELT FREQUNTLY LOCKS UP AND WILL NOT EXTEND ENOUGH TO SECURE A PERSON. SEAT BELT OFTEN LOCKS UP WHEN PASSENGER IS BELTED IN AND PASSENGER CANNOT MOVE.

Jul 05, 2005

DRIVER'S SEAT BELT SQUEAKS RANDOMLY, CAUSING A MAJOR DISTRACTION WHILE DRIVING UNTIL I FIGURED OUT IT WAS MY MOVEMENTS, CAUSING THE NOISE. WHENEVER I GET THE CHANCE TO TAKE IT IN FOR SERVICE, IT STOPS FOR WEEKS AT A TIME. DEALER STATED HE WOULD HAVE TO KEEP TRUCK AND CHECK IT OUT. IF A PROBLEM, THEN HE WOULD ORDER PARTS AND I COULD BRING IT IN AGAIN TO HAVE IT FIXED. I CANNOT LEAVE IT FOR DAYS, SO I HAVE NOT GONE BACK IN.*AK

Apr 26, 2005

+ 15 more complaints for this component

ELECTRICAL SYSTEM

19 complaints

ON MARCH 16, 2017, I WAS TRAVELLING ON A MOUNTAIN HIGHWAY IN NORTHERN CALIFORNIA IN MY 2001 SUBURBAN WITH THE DRIVER'S SEAT HEATER ON. I WAS SITTING ON A THIN SEAT CUSHION. TWENTY MINUTES INTO THE 40 MINUTE TRIP, I TURNED MY SEAT HEATER OFF. TEN OR SO MINUTES LATER, I SMELLED A HORRIBLE RUBBER/PLASTIC BURNING SMELL. WHEN I REACHED MY DESTINATION, I LIFTED MY CUSHION AND SAW THAT THE SEAT HAD A BURNED HOLE THROUGH THE LEATHER AND INTO MY SEAT CUSHION. IT WAS WARM, BUT I DID NOT SEE A FLAME. WHEN I GOT HOME IN THE BAY AREA, I CONTACTED GM, AND THEY OPENED A CASE NUMBER AND TOLD ME TO TAKE MY VEHICLE TO A DEALER, AND THEY WOULD INVESTIGATE. I RECEIVED A CALL YESTERDAY FROM THE CUSTOMER SERVICE REP., AND SHE TOLD ME THAT THEY WOULD NOT BE COVERING THIS AS MY CAR WAS OUT OF WARRANTY, IN SO MANY WORDS. I ASKED WHAT THE DEALER HAD FOUND, AND SHE COULDN'T TELL ME. I REITERATED TO HER THAT THIS IS A SAFETY CONCERN FOR ME. MY PASSENGER SIDE SEAT HEATER IS NOW GETTING VERY HOT, AND I AM CONCERNED NOW ABOUT THAT. PLEASE NOTE, THE DRIVER'S SEAT HEATER IS STILL WORKING IF YOU ACCIDENTALLY HIT THE BUTTON ON THE DOOR. TODAY, I FOUND OUT FROM THE DEALER THAT THEY WERE NOT INSTRUCTED BY GM TO LOOK INTO THE SEAT TO SEE WHAT CAUSED THIS, ONLY TO TAKE PICTURES, ETC. NOBODY KNOWS WHY IT HAPPENED. HOW CAN THEY DENY ANYTHING WITHOUT DETERMINING THE CAUSE IS MY THOUGHT. AREN'T THEY CONCERNED THEIR SEATS OVERHEAT? SHOULD THEY BE WARNING THE PUBLIC? MY SEATS ARE IN VERY GOOD CONDITION, EVEN THOUGH IT IS AN OLDER VEHICLE. INTERESTING TO NOTE WHEN WE PICKED THE CAR UP FROM THE DEALERSHIP THAT THE SERVICE WRITER SAID I SHOULDN'T WORRY SINCE IT IS NOT WORKING NOW BECAUSE A WIRED PROBABLY BROKE (EVERYTHING IS PROBABLY OR MAYBE). I CORRECTED HIM AND SHOWED HIM THAT IT DOES. HE WAS VERY SURPRISED TO SEE THAT IT STILL DID. SO, THE QUESTION IS WHY DID IT OVERHEAT. PLEASE ADVISE.

Apr 28, 2017

Fire: 1

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE STALLED. THE CONTACT ALSO MENTIONED THAT THE IGNITION WAS ABNORMALLY LOOSE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

Mar 14, 2014

MY VEHICLE'S "SERVICE ENGINE SOON" LIGHT CONTINUES TO LIGHT UP EVEN AFTER HAVING THE CODE ERASED. MANY OTHER OWNERS OF CHEVROLET SUBURBANS HAVE THE SAME ISSUE. OBD CODE P0332 STATES THE KNOCK SENSOR HAS LOW VOLTAGE. THE PROBLEM MANY PEOPLE HAVE IS WHEN WATER OR MOISTURE GETS INTO THE ENGINE COMPARTMENT WATER BEGINS TO POOL OVER THE SENSOR AND SEEP INTO THE SENSORS. THE LACKING OF WATER SEAL IN THIS POOLING AREA DAMAGES THE SENSORS. THE VEHICLE THUS CANNOT PASS IT'S BI-YEARLY SMOG TEST AND ALSO CREATES A FALSE SENSE OF VEHICLE RELIABILITY. IF OTHER ISSUES COME UP OTHER THAN THE BAD SENSORS THE DRIVER WOULD NEVER KNOW. *TR

Aug 21, 2013

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE LIGHTS ON THE INSTRUMENT PANEL STOPPED ILLUMINATING. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER STATED THAT THE INSTRUMENT PANEL NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 115,000 AND THE CURRENT MILEAGE WAS 145,000.

Jul 12, 2012

WIFE WAS DRIVING ON THE FREEWAY IN OUR SUBURBAN AND THE ENGINE SHUT OFF WITHOUT WARNING. SHE HAD TO COAST OVER 5 LANES OF TRAFFIC AND GET INTO THE EMERGENCY LANE. TRUCK STARTED AFTER 4 ATTEMPTS AND WORKED FINE FOR 2 MORE DAYS. IT THEN DIED 2 MORE TIMES IN ONE DAY WITHOUT WARNING. IT AGAIN STARTED FINE AFTER 4 TO 5 ATTEMPTS. THE CRANKSHAFT POSITION SENSOR IS DEFECTIVE AND THERE WAS A RECALL OF OTHER 2001 MODELS WITH THE 8.1L BUT IT DID NOT INCLUDE MY SEQUENCE. THIS PART IS FAULTY AND PUT MY WIFE'S LIFE IN DANGER. THEY SHOULD RECALL ALL 8.1L CRANKSHAFT SENSORS. THIS IS A ISSUE AND THERE ARE TONS OF THREADS ON MESSAGE BOARDS ABOUT THIS ISSUE. *TR

Jun 29, 2012

+ 14 more complaints for this component

SERVICE BRAKES, AIR

13 complaints

I WAS TAKING MY SUBURBAN IN FOR IT'S ANNUAL SAFETY INSPECTION AND WAS NOTIFIED BY MY MECHANIC THAT ONE OF THE VEHICLE'S BRAKE LINES (EXITING THE ABS PUMP) WAS LEAKING AND THAT ALL FIVE OF THE PRIMARY BRAKE LINES ARE EXTERNALLY RUSTED AND NEAR BREAKING. ALL FIVE LINES NEED TO BE REPLACED RESULTING IN VERY COSTLY REPAIRS. I HAVE SIX CHILDREN AND WE REGULARLY TRAVEL AS A FAMILY. THIS POTENTIAL FAILURE HAS JEOPARDIZED MY CHILDREN'S LIVES AND GM SHOULD BE HELD ACCOUNTABLE FOR SELLING AN INFERIOR PRODUCT. THE VEHICLE HAS 88,000 MILES AND IS REGULARLY MAINTAINED. *JS

Mar 19, 2012

HAVE A 2001 SUBURBAN LT ABOUT 10 TO 5 MPH THE ABS WILL START PUMPING THE BRAKES COMING TO A COMPLETE STOP OR PARKING IN A LOT WITH THE WHEEL TURNED. HAPPENDS ALOT. THIS ALL HAPPENING WITH NO RAIN. WHEN IT'S SUNNY AND DRY.

Aug 21, 2005

ON TUESDAY, JULY 19TH, I HAD 2001 CHEVROLET SUBURBAN SERVICED AT A LOCAL SHOP, WHERE I RECEIVED MY MANUFACTURER'S SUGGESTED 60K MAINTAINENCE, WHICH INCLUDED AN INSPECTION OF ALL MY PRIMARY SYSTEMS, INCLUDING BRAKE. NO PROBLEMS WERE REPORTED. ON FRIDAY, JULY 22, 2005, I WAS PULLING INTO MY DRIVEWAY AT APPROXIMATELY 3:45PM. AS I APPROACHED MY DRIVEWAY FROM THE STREET, I BEGAN BRAKING WITH THE INTENTION OF PARKING IN THE DRIVEWAY IN FRONT OF MY GARAGE; HOWEVER, RATHER THAN SIMPLY SLOWING DOWN, MY BRAKES INSTEAD MADE A STRANGE VIBRATION (SOUND AND MOVEMENT), AND THE BRAKES APPEARED TO MALFUNCTION. I ATTEMPTED TO PUMP MY BRAKES, BUT THE "VIBRATIONS" CONTINUED AND MY TRUCK SEEMED TO "SLIDE", EVEN THOUGH I WAS NOW PRESSING ON MY BRAKE PEDAL WITH ALL MY MIGHT. MY TRUCK OVERSHOT MY DRIVEWAY PARKING SPOT, AND CRASHED INTO MY GARAGE DOOR. THE VEHICLE DESTROYED THE GARAGE DOOR, AND THERE WAS FRONT END DAMAGE TO MY BUMPER, HOOD, GRILL AND WINDSHIELD. THE DRIVER'S AND PASSENGER'S AIRBAGS DID NOT DEPLOY. IMMEDIATELY AFTERWARDS, MY NEIGHBOR AND I INSPECTED THE BRAKE FLIUD, MASTER CYLINDER AND VISIBLE SYSTEMS, WHICH APPEARED INTACT, AND TEST DROVE THE VEHICLE AROUND THE NEIGHBORHOOD, WITHOUT FURTHER INCIDENCE. HOWEVER, I DID NOT DRIVE THE TRUCK UNTIL 2 DAYS LATER, WHEN I DROVE ON SUNDAY, JULY 24TH, AT WHICH TIME THE BRAKE "VIBRATIONS" RE-OCCURRED AS I PULLED INTO A TURN LANE INTO A SUPERMARKET PARKING LOT. I HAD THE TRUCK TOWED TO THE LOCAL CHEVROLET DEALERSHIP, AND AFTER THEIR BRAKE INSPECTION, I WAS TOLD THAT THE ABS WHEEL SPEED SENSOR NEEDED TO BE REPLACED, WHICH WOULD BE AT NO COST BECAUSE IT WAS "UNDER WARRENTY", AND THAT THEY ALSO WANTED TO REPLACE MY REAR ROTORS, AT A COST OF OVER $800. WHEN I ASKED CAROL, THE SERVICE REP, IF THE WHEEL SPEED SENSOR COULD HAVE CASUED MY BRAKE MALFUNCTION, SHE SAID POSSIBLY, BUT NO DEFINATELY. WHEN I ASKED IF THE REAR ROTORS COULD HAVE CONTRIBUTED, SHE SAID NO. NO OTHER BRAKING PROBLEMS WERE REPORTED.

Jul 26, 2005

Crash: 1

ROTORS RUSTED, PITTED, CORRODED AT ONLY 10,000 MILES; 15 MONTHS OLD. ALL TURNED, BUT WERE UNDER SPECIFICATIONS, SO DEALER HAD TO REPLACE (UNDER WARRANTY)

Jul 17, 2005

I HAVE 2 2001 CHEVYS WITH ABS PROBLEMS. SUBURBAN AND SILVERADO PICKUP. WHEN COMING TO A SLOW STOP, THE BRAKES WILL RELEASE LIKE ONE ICE, BUT ONE DRY PAVEMENT

Jun 06, 2005

+ 8 more complaints for this component

STRUCTURE

11 complaints

TL*THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 2500. THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH AND THE TRAILER HITCH BEGAN TO DRAG ON THE ROADWAY. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD AND INSPECTED. THE FRAME WAS CRACKED AND BENT SIGNIFICANTLY WHERE THE TRAILER HITCH WAS ATTACHED. THE CONTACT WAS ABLE TO RESUME OPERATION WITH CAUTION. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS APPROXIMATELY 121,000.

May 24, 2010

THE 2001 SUBURBAN'S BODY FRAME AND FRONT WHEEL WELLS ARE POORLY DESIGNED IN THAT THEY ALLOW EXTENSIVE AMOUNTS OF WATER SPRAY FROM FLOODED ROADWAYS TO SATURATE THE WINDSHIELD WHILE DRIVING, CAUSING THE DRIVERS VIEW OF THE ROAD TO BE COMPLETELY OBSTRUCTED CREATING AN UNSAFE DRIVING ENVIRONMENT. *TR

Mar 19, 2008

2001 SUBURBAN REAR FRAME RAILS BROKE OFF. *TS ***NO ANSWER REQUIRED*** THE CONSUMER STATED THE FRAME WAS NOT MADE WITH A THICK METAL. *JB

Dec 06, 2005

CONTACT STATES THIS PAST WEDNESDAY WHILE HIS WIFE WAS SHOPPING, SHE OPENED UP THE GLASS PORTION OF THE LIFTGATE. THEN SHE ALMOST SHUT IT, AND THEN SHE REACHED UNDER TO GET A HOLD OF THE LIFTGATE HANDLE AND RAISED THE ENTIRE LIFTGATE ABOVE HER HEAD .WHEN SHE RAISED THIS THE ENTIRE WINDSHIELD BROKE AND SHATTERED ON HER HEAD.. HE HAS TALKED TO THE DEALER ABOUT THIS, AND THEY SAID THAT THESE THINGS SOMETIMES HAPPEN. HE STATEED THAT THIS WAS NOT ACCEPTABLE TO HIM.*AK

Jun 27, 2005

THE TRUCKS BED CRACKED ON THREE SEPARATE OCCASIONS. *PH THE CONSUMER REQUESTED A FULL REFUND AND A GUARANTEE THAT THE VEHICLE WOULD BE INSPECTED. (MODEL/FLEETSIDE) *SC *JB

Mar 31, 2004

+ 6 more complaints for this component

FUEL SYSTEM, OTHER

11 complaints

2001 CHEVY SUBURBAN WITH VORTEC 5.3 L ENGINE. DURING HOT DAYS OR WARM ENGINE, THE THROTTLE STICKS IN "IDLE" POSITION, REQUIRING SIGNIFICANTLY HEAVIER PRESSURE ON THE ACCELERATOR PEDAL RESULTING IN A SUDDEN AND UNCONTROLLABLE ACCELERATION WHEN IT RELEASES FOR THE STUCK "IDLE" POSITION. THIS EVENT OCCURS AT IRREGULAR INTERVALS, ON THE VORTEC 5.3 ENGINE, AS A RELATIVE HAS A SIMILAR PROBLEM WITH THE CHEVY PICKUP AND THE SAME 2001 5.3 VORTEC ENGINE. *TR

Nov 15, 2008

ENGINE SHUTS OFF DURING FIRST INITIAL RUN. IF I LEAVE THE HOUSE AND GET TO THE STOP SIGN. IT WILL SHUT OFF. EVEN AFTER THE FIRST FEW MINUTES OF DRIVING WHEN I TRY TO TURN IT WILL SHUT OFF. AFTER THE ENGINE RUNS A WHILE IT OPERATES NORMALLY. *TR

Jun 09, 2008

WHILE DRIVING ON THE INTERSTATE AT 70 MPH, THE CAR SUDDENLY DIED. LUCKILY WE WERE GOING DOWN A HILL AND NO OTHER CARS NEARBY, SO WE COASTED TO THE SHOULDER. CAR WOULD NOT CRANK - IT WAS COMPLETELY DEAD. IT WAS TOWED TO DEALERSHIP. THEY SAID A FUSE WAS BLOWN WHICH CAUSED THE PROBLEM. THEY DID NOT KNOW WHY THE FUSE WAS BLOWN. THEY GAVE US SEVERAL EXTRA FUSES IN CASE IT HAPPENED AGAIN. WE WERE ON OUR WAY HOME FROM VACATION, SO WE TOOK THE EXTRA FUSES AND FINISHED THE TRIP HOME. A COUPLE DAYS LATER THE CAR WOULD NOT CRANK. WE TOOK IT TO THE LOCAL DEALER, WHO FOUND THAT THE FUEL PUMP WAS CAUSING THE FUSE TO BLOW. WE HAD TO PAY OVER $800 TO REPLACE THE FUEL PUMP. WE ARE HOPING THAT GM WILL RE-IMBURSE US, SINCE THIS SOUNDS SIMILAR TO THE RECALL. THEY SAY THAT EVEN THOUGH WE'VE HAD TO PAY FOR THE PROBLEM, WE CANNOT FILE ANY PAPERWORK UNTIL NOVEMBER. SO IT'LL BE AT LEAST UNTIL THEN BEFORE WE GET ANY MONEY BACK, IF AT ALL. IN THE MEANTIME, IT SOUNDS LIKE THE NEW FUEL PUMP IS SUSCEPTIBLE TO THE SAME PROBLEM.

Jul 21, 2005

I HAD MY CHEV. SUBURBAN 1500, YR. 2001 IN FOR THE 60,000 MI. SERVICE AND A NEW FUEL FILTER WAS REPLACED ACCORDING TO THE NEEDS. I HAD PROBLEMS RIGHT AWAY WITH FUEL BEING BELOW 1/4 TANK. IT WAS STALLING OUT. NO LOW ON FUEL LIGHT CAME ON, BUT THE SERVICE ENGINE SOON LIGHT DID. THAT WAS AT 1/8 OF A TANK. IT FELT LIKE I WAS GOING TO RUN OUT OF GAS. I REPORTED IT IMMEDIATELY TO THE OIL CAN HENREY'S WERE THE SERVICE WAS PREFORMED. THEY MANAGER GAVE ME A FUEL ADDITIVE. DIDN'T WORK. IF I GOT TO 1/4 TANK IT WOULD DO THE SAME THING. IT WAS RECOMMENDED TO ME THAT I HAVE A DIAGNOSTIC CHECK AT THE DEALER. THEY REPLACED THE FILTER AND SIAD IT WAS A DEFECT. THE PROBLEM IS STILL PRESENT, IT HAS BEEN 7 MONTHS, 2 FUEL FILTERS, 2 SENSORS, AND I STILL HAVE A PROBLEM. I HAVE TO TAKE IT BACK AGAIN, AND I TOOK IN THE RECALL SHEET THAT IS STILL UNDER INVESTIGATION ON MY MAKE AND MODEL. AND ALSO THE LAST TIME I WAS NOT ABLE TO FILL MY WHOLE TANK. IT WOULD ONLY TAKE ABOUT 18 GAL. AND SHUT OFF. ALL THE SYMPTOMS ARE WHAT IS DISCRIBED IN YOUR INVESTIGATION. PLEASE CONTACT ME.

Jun 02, 2005

SIGNIFICANT FUEL LEAK FROM GAS TANK OF 2001 CHEVROLET SUBURBAN. WILL LEAK AT APPROX. 1/2 GAL PER HOUR. WILL LEAK WHEN RUNNING AT IDLE, RUNNING AT SPEED, AND STOPPED, ENGINE OFF. PLEASE TAKE NOTE - THE VEHICLE WOULD STILL RUN WITH THE FUEL TANK LEAKING SIGNIFICANTLY. NO ERROR MESSAGE WAS DISPLAYED IN THE VEHICLE MESSAGE DISPLAY. NO FIRE OCCURRED, BUT WITH CLOSE PROXIMITY TO EXHAUST SYSTEM, RISK FOR FIRE WOULD APPEAR TO BE EXTREME. DELIVERED VEHICLE TO DEALER TO INSPECT. UPON PRESSURE TEST, DEALER FOUND LEAK AT TOP OF TANK IN PASS-THROUGH CONNECTOR. LEAK WAS OCCURRING BECAUSE WIRE INSIDE TANK (FUEL PUMP LEAD) MELTED, AND CREATED HOLE IN PASS THROUGH CONNECTOR. ENTIRE INTERNAL TANK FUEL PUMP AND FUEL LEVEL SENDER ASSEMBLY REPLACED. DEALER TECHNICIAN REPORTED HE HAD SEEN THIS BEFORE, BUT USUALLY THE VEHICLE WOULD NOT RUN, OR A CHECK ENGINE LIGHT WOULD BE DISPLAYED. THIS VEHICLE WOULD RUN, AND DID NOT DISPLAY ANY MESSAGE IN THE VEHICLE MESSAGE DISPLAY. DEALER WOULD NOT ACKNOWLEDGE A RECALL IN THEIR SYSTEMS OR SUPPORT A SAFETY ISSUE SEARCH. GM WOULD NOT ACKNOWLEDGE ANY RECALL OR SAFETY ISSUE CONCERN DURING CALLS PLACED ON 5-13-2005. GM SERVICE REQUEST WAS SUBMITTED BY OWNER VIA PHONE - OPEN SERVICE REQUST #1-335303835. COST TO REPAIR WAS $996.38US, ALL PAID BY OWNER. OWNER (ME) HAS ALL RECEIPTS AND DEFECTIVE PARTS. FAILED WIRE LEAD ON INTERNAL PUMP IS VISIBLY MELTED. CANNOT CONFIRM REPLACEMENT PART (GM # 25315983) IS NOT ALSO DEFECTIVE, AND MAY ALSO LEAD TO REOCCURENCE OF THE SAME PROBLEM - MELTED WIRE, GAS LEAK, POTENTIAL FIRE OR EXPLOSION.

May 13, 2005

+ 6 more complaints for this component

VEHICLE SPEED CONTROL

11 complaints

EVERY MORNING WHEN I START THE CAR, IT "LUNGES" FORWARD. THIS HAS ONLY HAPPENED 3 OR 4 TIMES DURING THE DAY BUT IT DOES HAPPEN EVERY MORNING. I KEEP THE CAR IN THE GARAGE SO WHEN IT DOES MOVE FORWARD IT IS ONLY A COUPLE OF INCHES, BUT WHEN I AM IN A PARKING LOT, I MAKE SURE TO LEAVE PLENTY OF ROOM BETWEEN CARS SO I DO NOT HIT ANYONE. I HAVE OWNED THIS VEHICLE SINCE JAN. 07 AND THIS JUST STARTED IN NOVEMBER. *TR

Dec 18, 2007

TL*THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THAT THE ACCELERATOR PEDAL WOULD STICK DURING THE INITIAL STARTING. THE FAILURE GENERALLY OCCURRED DURING WARM WEATHER. AS OF DECEMBER 11, 2007, THE DEALER HAD NOT INSPECTED THE VEHICLE. THE FAILURE MILEAGE WAS 68,000 AND CURRENT MILEAGE WAS 78,000. UPDATED 03/14/08. *LJ

Dec 11, 2007

DT: VEHICLE SPEED CONTROL MALFUNCTIONED. WHEN STARTING VEHICLE HAVD TO APPLY ADDITIONAL PRESSURE ON THE ACCELATOR, IT SEEMED TO BE STUCK. THIS ONLY HAPPEND WHEN PUTTING THE VEHICLE IN PARK OR REVERSE. THIS STARTED HAPPENING ON MAY 12, 2005. DEALER LOOKED AT VEHICLE BUT WAS GOING TO CHARGE THE CONSUMER FOR REPAIRS. NHTSA ACTION INVESTIGATION EA02015 DEALT WITH SAME PROBLEM. *AK

Aug 12, 2005

WHEN THE CONSUMER ATTEMPTED TO ACCELERATE FROM A STOP, THE ACCELERATOR PEDAL BECAME STUCK. THE CONSUMER HAD TO USE EXCESSIVE FORCE . THE CAUSE WAS NOT DETERMINED. PLEASE PROVIDE MORE INFORMATION. *JB

Jan 25, 2005

WHILE VEHICLE WAS PARKED WITH ENGINE RUNNING FOR 15 MINUTES AND WHEN ATTEMPTING TO DRIVE CONSUMER NOTICED THAT THE ACCELERATOR PEDAL WAS STUCK. THIS HAPPENED INTERMITTENTLY, USUALLY THE LONGER THE VEHICLE SAT. *AK

Aug 24, 2004

+ 6 more complaints for this component

ENGINE

6 complaints

EXHAUST AND MANIFOLD COVER BOLTS ARE TOO WEAK AND THE HEADS BREAK OFF. I HAD TO REPLACE ALL OF THEM WITH RACING BOLTS. MUCH BETTER NOW.

May 21, 2017

TL* THE CONTACT OWNED A 2001 CHEVROLET SUBURBAN. WHILE DRIVING THE VEHICLE, SMOKE EMITTED UNDER THE HOOD OF THE VEHICLE. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND EXITED THE VEHICLE. THE VEHICLE CAUGHT ON FIRE, WHICH WAS EXTINGUISHED BY THE FIRE DEPARTMENT. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED AND DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000. THE VIN WAS NOT AVAILABLE.

Oct 17, 2016

Fire: 1

WHEN VEHICLE IS IDLING WHILE NOT MOVING EXTREME AMOUNTS OF EXHAUST FUMES ARE ENTERING THE CABIN AREA THROUGH THE VENTILATION SYSTEM. THIS IS DUE TO DEFECTIVE EXHAUST MANIFOLD BOLTS WHICH ARE BREAKING ALLOWING THE EXHAUST MANIFOLD TO OPEN AND ALLOW FUMES TO ENTER THE ENGINE COMPARTMENT WHICH RESULTS IN THE EXHAUST FUMES ENTERING THE PASSENGER CABIN AREA THROUGH THE VENTILATION SYSTEM. THIS IS A HEALTH ISSUE FOR PASSENGERS INSIDE THE CABIN BREATHING THE TOXIC EXHAUST FUMES. THIS SHOULD BE A SAFETY RECALL ON GM TO FIX THE PROBLEM DUE TO POOR ENGINEERING DESIGN AND FOR USING POOR QUALITY COMPONENTS WHICH FAIL FOR NO REASON. ALSO THIS IS AN EXTREMELY DANGEROUS SITUATION FOR PASSENGERS INSIDE THE VEHICLE, WHICH HAVE TO BREATH THE DANGEROUS EXHAUST FUMES. GM SHOULD BE MADE TO REPAIR ALL VEHICLES AFFECTED BY THIS PROBLEM WHICH WERE DESIGNED AND ENGINEERED WITH INFERIOR PARTS WHICH ARE CAUSING THIS DANGEROUS SITUATION FOR MILLIONS OF PEOPLE ACROSS THIS COUNTRY.

Dec 31, 2015

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE ENGINE STALLED WITHOUT WARNING. THE ENGINE WARNING LIGHT ILLUMINATED PRIOR TO THE FAILURE. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING, WHICH LOCATED A FAILURE CODE AT THE CRANKSHAFT POSITION SENSOR. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V521000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 101,000.

Oct 20, 2015

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 1500. WHILE DRIVING AT 65 MPH, THE ENGINE STALLED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 180,000. UPDATED 7/28/15*CN UPDATED 10/18/2017*CN

Jun 02, 2015

+ 1 more complaint for this component

UNKNOWN OR OTHER

5 complaints

THE PASSENGER SIDE REAR DOOR WINDOW BREAKS WHEN THE WINDOW IS DOWN FOR NO REASON. I HAVE HAD TO REPLACE IT 4 TIMES IN THE LAST 60 DAYS. THERE APPEARS TO BE NO DAMMAGE TO ANY OF THE INSIDE OF WINDOW OR THE WINDOW REGULATOR. THE VEHICLE WAS STATIONARY AND MY DAUGHTER OPENED THE DOOR AND THE WINDOW BROKE.

Sep 08, 2017

PREMATURE REAR SECTION OF BRAKE LINE RUST OUT 2001 CHEVY SUBURBAN.

Dec 02, 2015

I HAVE A 2001 SUBURBAN WITH 65000 MILES THAT INTERMITENTLY STALLS WHILE DRIVING AND DOESN'T IMMEDIATELY RESTART. THE PROBLEM HAS OCCURRED IN HOT AND COLD WEATHER, AND OCCURS WHILE DRIVING AT HIGHWAY SPEEDS, NEIGHBORHOOD SPEEDS, AND SLOWING TO STOP SPEEDS. USUALLY THE VEHICLE RE-STARTS AFTER 10 MINUTES, BUT IT HAS TAKEN AS LONG AS 45 MINUTES BEFORE IT WILL START. THE VEHICLE ALSO INTERMITENTLY WILL NOT START AFTER BEING PARKED FOR VARIABLE LENGTHS OF TIME. THE VEHICLE HAS BEEN TO TWO DIFFERENT DEALERSHIPS WITH THE SAME RESULT: CAN'T DUPLICATE THE PROBLEM SO CAN'T FIX IT. I CALL THE CHEVROLET CUSTOMER ASSISTANCE CENTER AND THEY TELL ME TO TAKE IT TO A DEALER FOR A DIAGNOSIS, WHICH HAS BEEN DONE MULTIPLE TIMES. THE LAST DEALER PERFORMED COMPLETE DIAGNOSTIC TESTING AND FOUND NOTHING WRONG. MEANWHILE, I READ MANY ARTICLES AND POSTINGS ABOUT OTHER SUBURBANS EXHIBITING THE SAME BEHAVIOR- STALLING AND NOT STARTING. AND MEANWHILE, I GET TO DRIVE A VEHICLE THAT PUTS MY FAMILY IN DANGEROUS SITUATIONS. WHILE THERE HAVE BEEN NO INJURIES, ACCIDENTS OR DEATHS CAUSED BY THIS BEHAVIOR, YET, I AM CONCERNED ABOUT THE SAFETY OF MY FAMILY WHILE RIDING IN A VEHICLE THAT COULD STALL AT ANY TIME, WITH LIMITED CONTROL OF BRAKING AND STEERING. CHEVROLET NEEDS TO STEP UP AND TAKE OWNERSHIP OF THIS PROBLEM AND DO SOMETHING BEFORE PEOPLE DIE.

Jul 12, 2005

THE REAR PASSENGER AS WELL AS FRONT DRIVER AND PASSENGER SIDE DOORS WERE NOT EQUIPPED DOOR CHIMES. THE DEALER STATED THAT THERE WAS NOTHING THEY COULD DO. *AK THE CONSUMER STARTED TO DRIVE AND WHEN HE MADE A LEFT TURN, THE DOOR SWUNG OPEN. THE CHILD NEARLY FELL OUT OF THE VEHICLE. THERE WERE NO WARNING CHIMES TO ALERT THE CONSUMER THAT THE DOOR OPENED. *SCC *JB

Aug 15, 2003

AFTER PURCHASING THIS VEHICLE, WE BEGAN TO NOTICE THAT THE "DOOR AJAR" INDICATOR SEEMED TO BE MALFUNCTIONING, AND BROUGHT IT TO THE DEALERSHIP FOR WARRANTY SERVICE. ON 5 SEPARATE OCCASIONS, A PASSENGER DOOR WAS DISCOVERED AJAR WHILE I WAS DRIVING, BUT THERE WAS NO WARNING OR INDICATOR IN THE DASH TO ALERT THIS TO THE DRIVER. THE COMPUTER INFORMATION SYSTEM IN THE DASH WILL INDICATE IF THE REAR CARGO DOOR IS AJAR, BUT NOT ANY OF THE PASSENGER DOORS, FRONT, REAR OR DRIVER. THE SERVICE DEPARTMENT AT MY DEALERSHIP HAS INFORMED ME TODAY THAT THERE IS NO SUCH INDICATOR DESIGNED FOR THIS VEHICLE. I CALLED CHEVROLET DIRECTLY AND WAS INFORMED THAT I "SHOULD HAVE CONSIDERED THIS 'OPTION' BEFORE I PURCHASED MY VEHICLE." THE DEALERSHIP HAS CONFIRMED TO ME THAT THERE IS NO "OPTION" FOR A DOOR AJAR INDICATOR; IN FACT, IT ISN'T EVEN AVAILABLE ON THIS YEAR'S 2002 MODEL, EITHER. I HONESTLY FEAR FOR THE LIVES OF MY 4 CHILDREN, WHO RIDE IN THE BACK SEATS OF THIS VEHICLE EVERY DAY. HOW CAN A MANUFACTURER MARKET THIS VEHICLE TO "MEET THE NEEDS OF THE AMERICAN FAMILY" WHEN BASIC, STANDARD SAFETY INDICATORS WEREN'T EVEN INCLUDED ON THIS "TOP OF THE LINE" VEHICLE? THEY ARE LEAVING THEMSELVES OPEN FOR A HUGE LAWSUIT WHEN SOMEONE'S CHILD FINALLY DOES FALL OUT OF THE SUBURBAN, "LIKE A ROCK."*AK

Jul 18, 2002

FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM

5 complaints

FIRST INCIDENT: VEH. WOULD CRANK BUT NOT START. TURNED OUT TO BE FUEL DELIVERY FUSE. REPLACED, AND RAN FINE FOR SEVERAL WEEKS. SECOND INCIDENT: DRIVING AT APPROX. 55 MPH, VEHICLE LOST POWER, STARTED SPUTTERING AS IF OUT OF GAS ALTHOUGH IT WAS 1/4 FULL. UNABLE TO EXCEED 25 MPH DUE TO LITTLE/NO POWER. WAS TOWED TO AUTOPARTS STORE, CLEARED CODES, VEH RAN FINE FOR ABOUT 2 DAYS, THEN LOST POWER. TOWED HOME. LOOKED UP INFO ON INTERNET, FOUND RECALLS FOR FUEL PUMP. CALLED LOCAL CHEVY DEALERSHIP, INQUIRED ABOUT RECALL, WAS TOLD THAT RECALL WAS ONLY ON HALF-TON SUBURBANS AND SINCE MINE IS 3/4 TON, IT WAS NOT COVERED BY RECALL. I REPLACED FUEL MODULE MYSELF AND DISCOVERED THE COVERING OF THE WIRES INSIDE THE FUEL MODULE ASSEMBLY HAD MELTED, ALLOWING THE BARE WIRES TO RUB AGAINST EACH OTHER, SHORTING OUT THE FUEL DELIVERY SYSTEM (WHICH LIKELY CAUSED THE BLOWN FUSE TO BEGIN WITH). I AM VERY UPSET THAT MY SUBURBAN IS NOT COVERED BY THE RECALL, EVEN THOUGH IT IS VIRTUALLY THE SAME SYSTEM AS WHAT IS IN THE THE 1/2 TON SUBURBANS, AND THE SAME PROBLEM EXISTS (AS EVIDENCED BY NOT ONLY MY OWN EXPERIENCE, BUT MANY OTHERS' EXPERIENCES AS WELL). I AM EXTREMELY DISTURBED THAT UNDER THE RIGHT CIRCUMSTANCES, FUEL VAPORS, PLUS SPARK OF BARE WIRES TOUCHING, COULD IGNITE, CAUSING FIRE AND/OR EXPLOSION. POSSIBLY WITH MY FAMILY OF SIX IN THE VEHICLE.

Nov 12, 2010

TL*THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH WHEN HE NOTICED THAT THE FUEL GAUGE DISPLAYED EMPTY WHICH WAS INACCURATE; HOWEVER, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TOWED TO HIS RESIDENCE. THE CONTACT REPAIRED THE VEHICLE BY REPLACING THE FUEL PUMP MODULE. THE FAILURE MILEAGE WAS APPROXIMATELY 69,000. UPDATED 08/24/10 *LJ THE CONSUMER STATED THE ELECTRICAL WRING IN THE FUEL PUMP MODULE HAD MELTED THE INSULATION AND WAS CAUSING A SHORT IN SEVERAL PLACED. UPDATED 08/24/10

Jul 01, 2010

DT: THE CONSUMER OWNS A 2001 CHEVROLET SUBURBAN. IN OCTOBER 2004 THE VEHICLE QUIT. A FUSE WAS REPLACED AT A COST OF $137.75. THIS AMOUNT INCLUDED THE TOWING FEE. ON 12-07-04, THE VEHICLE EXPERIENCED THE SAME PROBLEM. THE CONSUMER HAD TO PAY $306.00 TO HAVE ANOTHER FUSE REPLACED. THIS INCLUDED DIAGNOSTIC FEES. ON 12-14-04, THE SAME PROBLEM OCCURRED AND THE DEALER REPLACED THE FUEL PUMP AT A COST OF $567.55. THE CONTACT RECEIVED RECALL CAMPAIGN# 05V155000 CONCERNING THE FUEL PUMP ABOUT THREE-FOUR MONTHS AGO. THE DEALER AND GENERAL MOTORS REFUSED TO REIMBURSE THE CONSUMER FOR THE AFOREMENTIONED WORK PERFORMED BECAUSE THE RECALL HADN'T OCCURRED. THE RECALL STATED THAT THE CONSUMER WOULD BE NOTIFIED ON 10-19-05 BECAUSE THE PARTS WERE AVAILABLE. THE CONSUMER THOUGHT THAT THIS WAS A VERY UNUSUAL AMOUNT OF TIME FOR HIM TO WAIT FOR REIMBURSEMENT. *AK (11/22/05) *SC

Oct 17, 2005

WIRING TO FUEL PUMP INSIDE OF GAS TANK GETTING HOT ENOUGH TO MELT WIRE INSULATION AND PLASTIC CONNECTOR RESULTING IN GAS LEAK AT FUEL PUMP MODULE. HAD REPLACE FUEL PUMP MODULE, BUT ITS MY CONCERN THAT A FIRE COULD BE CAUSED BY OVERHEATED WIRES INSIDE OF FUEL TANK. *JB

Aug 22, 2004

FUEL PUMP WIRING MELTED INSIDE GAS TANK AND CAUSED VEHICLE TO STALL AT HIGHWAY SPEED IN HEAVY TRAFFIC. POWER STEERING AND POWER BRAKES WERE LOST MAKING IT DIFFICULT TO CONTROL VEHICLE AND SAFELY GET TO THE SHOULDER. MECHANIC WHO REPLACED THE PUMP OWNS AN OLDER SUBURBAN AND HAD HIS FUEL PUMP FAIL MULTIPLE TIMES UNTIL HE REPLACED IT WITH AN AFTERMARKET PUMP. *JB

Aug 18, 2004

VISIBILITY

5 complaints

24 HOURS PREVIOUS THE DRIVER SIDE WINDOW SWITCH MADE A CLICKING SOUND. THE CAR THEN CAUGHT ON FIRE AT THE DOOR, BURNING TO THE FRAME. *TR

Jan 07, 2009

Fire: 1

THE 2001 CHEVROLET SUBURBAN WHICH I OWN LEAKS COLD AIR ON THE FRONT PASSENGER FEET. I WAS TOLD BY MY INSURANCE CO. THERE MAY HAVE BEEN A RECALL BY GM ON THIS AS IT IS A DEFECT IN THE CONSTRUCTION OF THE HEATING DUCT, IT EVIDENTLY FALLS APART AND COLD AIR FROM OUTSIDE POURS ONTO THE PASSENGERS FEET. *TR

Dec 16, 2007

THE AUTO-DIMMING HEATED MIRROR ON MY 2001 CHEVY SUBURBAN SUDDENLY CRACKED AFTER BUMPING INTO THE SIDE OF MY GARAGE DOOR. THE MIRROR IMMEDIATELY STARTED DRIPPING A GREEN SUBSTANCE ON THE DRIVEWAY. I STARTED TO CLEAN UP THIS SUBSTANCE WITH MY BARE HANDS WHICH CAUSED A BURNING SENSATION. I THEN NOTICED THAT THE GREEN LIQUID WAS DISCOLORING/MELTING THE PAINT ON THE SIDE OF MY VEHICLE AND EATING THE CONCRETE IN MY DRIVEWAY. I SPRAYED THE AREAS DOWN WITH WATER AND FOUND THE PAINT ON MY VEHICLE DAMAGED. MY SKIN BECAME VERY RED AND IRRITATED AFTER CONTACTING THIS MATERIAL. I CAN NOT BELIEVE THAT GM COULD KNOWINGLY SELL A PRODUCT TO THE PUBLIC WITH NO WARNING OF ANY KIND. THE BLACK PLASTIC HOUSING OF THE OUTSIDE OF THE MIRROR ALSO HAS MELTED DUE TO CONTACT WITH THE MATERIAL. I WANT TO KNOW WHAT THIS MATERIAL IS AND WHAT HEALTH PROBLEMS I CAN EXPECT TO HAVE DUE TO MY DIRECT CONTACT. I WANT TO HAVE ACCESS TO AN MSDS REPORT FOR UNKNOWN MATERIAL. THIS IS A VERY CAUSTIC CHEMICAL. *JB

Apr 16, 2007

Injuries: 1

DT*: THE CONTACT STATED THE DRIVER'S SIDE REARVIEW MIRROR WAS REFLECTING DOUBLE IMAGES CAUSING CONFUSION WHILE DRIVING AT NIGHT. THE VEHICLE WAS TAKEN TO THE DEALER WHO DETERMINED THE MIRROR DELAMINATED AND NEEDED TO BE REPLACED.

Oct 10, 2006

WINDSHIELD HAD STARTED CRACKING ON DRIVER'S SIDE ON DECEMBER 29, 2000, AND IN MARCH OF THIS YEAR HAPPENED ON PASSENGER'S SIDE. DEFECT STARTED WITHOUT BEING HIT.*AK

Mar 13, 2001

SUSPENSION

4 complaints

I PURCHUSED 2001 SUBURBAN AND TRIED TO CONTACT THE RECALL PEOPLE AT 18006302438 ABOUT RECALL #54628-05V379000.THEY TOLD ME THAT THEY COULD NOT HELP ME BECAUSE THE SERVICE ALREADY BEEN DONE. BUT THE VEHICLE IS DOING THE SAME THING THE RECALL SAID ITS DOING. *TR

Mar 10, 2013

2001SUBURBAN Z55 AUTORIDE SUSPENSION, NOT WORKING. HARSH RIDE WITHOUT SHOCK DAMPERING. DEALRER EXAMINED WITH NO CODE PROBLEMS. HOWEVER, HARSH RIDE CONTINUES. HELP. *LA

May 28, 2004

CONSUMER STATES THAT THE TWO FRONT BOLTS THAT HOLD THE FRONT END WILL COME LOOSE AND THE FRONT END WILL START TO RATTLE. CONTACTED DEALER AND THE DEALER IS NOT WILLING TO DO ANYTHING. MR

Oct 16, 2002

RECEIVER WELD BROKE CAUSING TRAILER TO SWING AND ROLL SUBURBAN. *AK

Dec 30, 2001

Crash: 1

STEERING,SERVICE BRAKES, HYDRAULIC

4 complaints

AFTER TOWING OUR TRAVEL TRAILER 60 MILES, MY WIFE WAS BACKING SUBURBAN INTO THE DRIVEWAY AND PULLED FORWARD TO ADJUST THE TRAILER ANGLE AND LOST ALL STEERING. WHEN I WENT TO SEE WHAT IT WAS DOING, NOTICED THAT THE BRAKES WERE ALSO VERY DIFFICULT TO OPERATE. WAS ABLE TO BACK THE TRAILER INTO THE DRIVEWAY WITH MUCH EFFORT TO ADJUST THE STEERING. HATE TO THINK WHAT WOULD HAVE HAPPENED IF IT WENT WHILE TOWING A TRAILER ON THE HIGHWAY WITH THE RUSH HOUR TRAFFIC. VERIFIED FLUID WAS FULL AND BELT AND PULLEY WERE SPINNING NORMALLY. MECHANIC SUGGESTED TO CHECK PULLEY, WAS ABLE TO MOVE IT FORWARD FROM THE POWER STEERING UNIT EASILY WITH A SCREW DRIVER. *KB

Oct 11, 2011

WHILE ATTEMPTING TO DEPART FROM PICKING UP OUT TRAVEL TRAILER, BOTH THE POWER STEERING AND BRAKES WENT OUT ON OUR 2500 4 WHEEL DRIVE SUBURBAN. THE ONLY THING THAT STOPPED THE SUBURBAN WAS THE TRAILER'S BRAKES. LUCKLY WE WERE STILL IN THE PARKING LOT AND THEREFORE GOING SLOW. UPON EXAIMINATION, I PULLED THE SURPINETINE BELT OFF AND THE POWER STEERING PULLY AND SHAFT CAME OFF. FROM WHAT I UNDERSTAND THE STEERING AND THE BRAKES ARE CONNECTED. THIS CAN ALSO HAPPEN WHEN THE BRAKE BOOSTER GOES OUT. THE GOOD THING IS THAT THIS NOT ONLY HAPPENED IN TOWN BUT NOT ON THE FREEWAY GOING DOWN A GRADE PULLING A 9,000 LBS TRAILER. I HAVE REPLACED THE POWER STEERING PUMP AND AM IN THE PROCESS OF HAVING THE BRAKES BLEED AS THEY DON'T "FEEL" RIGHT.*AK

Mar 08, 2004

WHILE DRIVING AT HIGHWAY SPEEDS POWER STEERING AND BRAKES FAIL, RESULTING LOSS OF POWER STEERING AND BRAKES SIMULTANEOUSLY. THIS IS DUE TO THE FAILURE OF THE POWER ASSIST AND POWER STEERING PUMP. THIS IS THE SECOND TIME THESE COMPONENTS HAVE BEEN REPLACED. THIS WAS FIRST NOTICED AND REPLACED IN JANUARY 2002. THE SECOND TIME OCCURRED IN FEBRUARY 2003. ON 6/11/2003 THE VEHICLE AGAIN SHOWED INDICATIONS OF A PROBLEM WITH THE BRAKES AND STEERING. THE BRAKE PEDAL BEGAN TO PULSATE, AND A HIGH-PITCHED WHINE COULD BE HEARD WHEN TURNING THE STEERING WHEEL. THE VEHICLE ALSO EXPERIENCES PROBLEMS WHEN BRAKING OVER ROUGH ROAD, SUCH AS RUMBLE STRIPS. AS THIS IS A THIRD PROBLEM WITH THESE CRITICAL COMPONENTS, THE SAFETY OF THIS VEHICLE IS IN QUESTION. THE LAST VISIT TO THE DEALER WAS SAID TO BE LOOSE BOLTS ON THE POWER STEERING GEAR BOX. THE POWER ASSIST DESIGN IS A KNOWN PROBLEM WITH THIS VEHICLE. I HAVE SPOKEN WITH SERVICE WRITERS, SERVICE MANAGERS AND HAVE READ OTHER REPORTS CONCERNING OTHER INCIDENTS LIKE I EXPERIENCED WITH THIS VEHICLE. *NLM

Jun 14, 2003

SIMULTANEOUS FAILURE OF BRAKE AND POWER STEERING SYSTEM WHILE TOWING A 25 FOOT TRAILER.. BOTH SYSTEMS RUN OFF SAME BELT. POWER STEERING SEIZED AND BROKE BELT.

Sep 25, 2001

SEATS

4 complaints

I HAVE A 2001 CHEVY SUBURBAN 1500 WHILE GOING OVER A SPEED BUMP AT THE SPEED OF 20MPH THE LUMBAR SUPPORT IN MY DRIVER'S SEAT "POPPED". WE HEARD A VERY LOUD EXPLODING SOUND AND AT THE SAME TIME I FELT A EXTREME PRESSURE AND PAIN IN MY LOWER BACK... I NOW HAVE LOWER BACK PAIN A DAY LATER. *TR

Dec 16, 2009

I OWN A 2001 CHEVY SUBURBAN 1500, THE MIDDLE ROW BENCH SEAT IS A 70/30 SPLIT. THE BOTTOM ( PART YOU SIT ON) OF THE LARGER SIDE (BEHIND DRIVERS SEAT TO MIDDLE OF VEHICLE) WILL NOT STAY LATCHED OR "LOCKED" INTO PLACE. I CONTACTED GM AND THEY SAID THAT SINCE MY SUBURBAN HAS MORE THAN 100,000 MILES ON IT THEY ARE NOT RESPONSIBLE FOR ANY ISSUES OR DEFECTS. VERY FRUSTRATING! THIS IS A TOTAL SAFETY CONCERN, SPECIALLY SINCE I HAVE FOUR CHILDREN WHO RIDE IN THIS TRUCK! *TR

Dec 09, 2009

REAR SEAT HEADREST CANNOT BE REMOVED TO ALLOW REAR SEAT TO FOLD DOWN WITHOUT MOVING FRONT SEAT FORWARD. MOVING THE FRONT SEAT FORWARD TO ALLOW THE REAR SEAT TO FOLD DOWN TO MAXIMIZE CARGO AREA CREATES AN UNSAFE DRIVING POSITION. OWNERS MANUAL DEPICTS HEADREST RELEASES THAT WOULD CORRECT THIS UNSAFE CONDITION. THESE WERE NOT SUPPLIED WITH THIS VEHICLE. MANUFACTURER REFUSED TO CORRECT DESIGN DEFECT. *AK

Sep 20, 2001

DRIVER'S SIDE, SECOND ROW SEAT DOES NOT HOLD ANY BRAND/STYLE CHILD SAFETY SEAT. DEALER'S SERVICE CENTER HAS CONFIRMED THIS PROBLEM, DENIES ANY DEFECT.*AK

Aug 28, 2001

WHEELS

3 complaints

I WAS DRIVING ON THE HIGHWAY 95 COMING BACK FROM DAYTONA WHEN A DRIVER LET ME KNOW THAT MY TIRES WHERE LOW SO I WHEN TO A GAS STATION TO PUT SOME AIR IN AND THATS WHEN I NOTICE THAT MY TIRES HAD A LOT OF NAILS LTHE 4 TIRES. THIS IS RIDICULOUS. MY TIRES ARE LNOT EVEN 2 YEARS OLD AND I HAVE THE RECEIPT TO PROVE IT. SOMEONE HAS TO DO SOMETHING. BECAUSE I HAVE A NEW BORN BABY WITH ME AND DRIVING WITH FLAT TIRES IS NOT AN OPTION. PLEASE TAKE MY COMPLAINT IN CONSIDERARATION. THANK YOU

Feb 10, 2017

TL*THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THAT THREE OF THE FOUR WHEELS HAVE FAILED ON THE VEHICLE. THE WELDS DETACHED FROM ONE OF THE RIMS AND CAUSED A FLAT TIRE. THE CONTACT STATED THAT THE VEHICLE BEGAN TO VIBRATE. THE CONTACT HAS PICTURES OF THE VEHICLE. THE CURRENT MILEAGE IS 141,352 AND FAILURE MILEAGE WAS 106,532. THE CONSUMER STATES THAT THE VEHICLE IS OWNED BY MIDDLEBURGH CENTRAL SCHOOL. THE CONSUMER PROVIDED COPY OF INVOICE. UPDATE 05/23/07 *TR

May 08, 2007

THIS IS CONCERNING A '01 Z71 SUBURBAN. HAD TIRES CHANGED DUE TO UNEXPLAINABLE VIBRATION IN WHEELS. AFTER TIRE CHANGE TIRES DEFLATED. FOUND ALUMINUM ALLOY RIMS SEVERELY RUSTED AND PITTED ON THE BACK SIDE, FOUND ONE RIM HAS A HOLE THE SIZE OF A PEA AFTER BRUSHING SOME RUST AWAY. *JB

Dec 12, 2004

VISIBILITY,STRUCTURE

3 complaints

DRIVING AT 65 MPH DOWN THE INTERSTATE, SUDDENLY THE SUNROOF GLASS SEPARATED FROM THE FRAME AND FLEW AWAY INTO THE ROAD BEHIND US. THE INSIDE SUN SHADE WAS ALSO SUCKED OUT. THE SUNROOF WAS CLOSED AT THE TIME. THE FRAME AND MOTOR ARE INTACT AND STILL OPERATE NORMALLY. SUNROOF WAS MADE BY VERMEULEN-HOLLANDIA, MODEL: TVS S/N 461569. THERE IS A RECALL ON 2002-UP MODELS FROM THEM BUT NOT FOR THIS SERIAL NUMBER. COMPANY NAME IS NOW WEBASTO. *TR

Apr 27, 2015

I HAVE SUBURBAN 2001, THE REAR WINDOW (TAILGATE WINDOW) GLASS SEPARATED FROM THE HINGES SUDDENLY. THIS IS COMMON PROBLEM IN GM SUBURBANS AND I AM AFRAID THIS MAY RESULT IN A SERIOUS ACCIDENT AS THE TAILGATE WINDOW MAY SEPARATE, FLY OFF AND HIT SOMETHING. I AM NOT SURE IF THE WINDOW WILL FLY OFF, MINE WAS HANGING FROM ONE HINGE UNTIL I CORRECTED IT. *TR

Sep 19, 2010

CONSUMER STATED THE DOOR PANEL WAS LOOSE, THE BUMPER LIGHT WAS BROKE, AND THE AIR BAG LIGHT ILLUMINATED, AND ALSO THE DRIVER SIDE PANEL HEATS FASTER THAN THE PASSEWNGERS SIDE.*YH

Apr 09, 2002

FUEL/PROPULSION SYSTEM

3 complaints

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE FUEL PUMP WAS DISABLED AND THE ODOR OF FUEL WAS PRESENT. ALSO, THE CONTACT INDICATED THAT THE FUEL GAUGE DISPLAYED INACCURATE FUEL LEVELS WHILE OPERATING THE VEHICLE AND THE SERVICE ENGINE SENSOR LIGHT HAD ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V155000 (FUEL SYSTEM, GASOLINE). THE CONTACT STATED THAT THE VEHICLE EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 260,000.

Mar 31, 2015

I HAVE OWNED MY 2001 CHEVY SUBURBAN SINCE JANUARY OF 2008. I HAVE REPLACED THE FUEL PUMP 3 TIMES AND TODAY WILL BE MY 4TH. I HAVE SPENT THOUSANDS OF DOLLARS ON THE SAME PART OVER AND OVER. THE LAST TIME IT WAS REPLACED MY MECHANIC ADVISED US TO KEEP AT LEAST 1/4 TANK OF GAS IN THE TANK WHICH I HAVE TRIED TO DO. BUT EVEN DOING THIS THE FUEL PUMP SEEMS TO GO ABOUT EVERY 15 MONTHS, JUST OUTSIDE THE WARRANTY. ITS RIDICULOUS, THERE IS NO WAY I SHOULD BE REPLACING FUEL PUMPS AT THIS RATE. *TR

Mar 29, 2013

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE ENGINE FAILED TO START. THE CONTACT HAD TO DEPRESS THE ACCELERATOR PEDAL AND TURN THE KEY IN ORDER TO START THE ENGINE. THE VEHICLE WAS TAKEN TO A MECHANIC FOR INSPECTION AND THEY STATED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 60,000.

Mar 07, 2013

SERVICE BRAKES, HYDRAULIC,PARKING BRAKE

3 complaints

I WAS DRIVING MY 2001 SUBURBAN AND WHEN I STEPPED ON THE BRAKES, THE PEDAL WENT TO THE FLOOR. NO WARNING OR BRAKE LIGHT CAME ON. I WAS ABLE TO LIMP THE TRUCK HOME AND I SAW THE REAR AXLE WAS WET WITH BRAKEFLUID. THE LEFT REAR BRAKE LINE HAD ROTTED AND BROKE. THE TRUCK IS VERY WELL KEPT UP AND I ALWAYS PRESSURE WASH THE UNDERCARRIAGE AFTER THE SNOW & WINTER. *KB

Oct 12, 2011

CONSUMER TOOK VEHICLE TO HAVE A STATE INSPECTION DONE AND FOUND THAT THE PARKING BRAKE WAS NOT HOLDING THE VEHICLE. IT WAS TAKEN TO THE CHEVROLET DEALER, AND THEY FOUND THAT THE PARKING BRAKE SHOES WERE WORN OUT, AND BOTH BRAKE ROTORS NEEDED TO BE REPLACED. *AK

May 19, 2004

I TOOK MY 2001 SUBURBAN TO HAVE A STATE INSPECTION DONE AND FOUND THAT THE PARKING BRAKE WAS NOT HOLDING. I THEN TOOK THE VEHICLE TO THE CHEVROLET DEALER AND THEY FOUND THAT THE PARKING BRAKE SHOES WERE WORN ALL THE WAY DOWN AND BOTH ROTORS NEEDED REPLACEMENT BECAUSE THEY WERE RUSTED INSIDE AND THE PARKING BAKE SHOES WOULD NOT HOLD. I ONLY HAVE 37000 MILES ON THE VEHICLE. THE DEALER WAS ONLY WILLING TO SPLIT THE COST OF THE ROTORS AND THE INSTALLATION OF THE ROTORS EVEN THOUGH THE PARKING BAKE WORE OUT AFTER ONLY 37000 MILES OR EVEN LESS. THE DEALER REPORTED THAT THE PARKING BRAKE SHOULD LAST LONGER THAN 37000 MILES. I AM THE ONLY PERSON WHO DRIVES THIS VEHICLE AND THE PARKING BRAKE WAS NEVER LEFT ON WHILE DRIVING. THERE IS A DEFECT ON THE ENGINEERING OF THE PARKING BRAKE SYSTEM THAT IT WEARS OUT THIS FAST WITH ONLY BEING USED WHEN THE VEHICLE IS PARKED.

Jan 06, 2004

ELECTRICAL SYSTEM,VISIBILITY

3 complaints

WIPER MOTOR FAIL. 2001 SUBURBAN 6.0L V8. WIPER MOTOR FAIL. THE WIPER MOTOR IN MY TRUCK ALWAYS FAILS. THE LAST TIME IT FAILED WAS SEPTEMBER 27TH 2010 DURING A HEAVY RAIN STORM. TO MAKE A LONG STORY SHORT I ALMOST RAN OVER A PEDESTRIAN, AND ENDED UP ON THE SIDEWALK. (TECHNICALLY THAT IS A CRASH) THE WIPER MOTOR JUST STOPPED WHILE IT WAS RAINING. LAST YEAR DURING HEAVY SNOW THE MOTOR FAILED AGAIN. I HAD TO PULL OVER FOR AN HOUR UNTIL THE STORM WAS OVER. NOT TO MENTION NUMEROUS OTHER TIMES AS WELL. THIS MOTOR FAILS A LOT I LOST COUNT. THE EVENTS THAT LEAD UP TO THE FAILED WIPER MOTOR ARE RAIN , SNOW, SLEET, SOMETIME THE MOTOR FAILS DURING A SUNNY DAY AND NO MOISTURE IN THE AIR OR FAILED JUST TO CLEAN YOUR WINDOW. NOTHING HAS BEEN DONE TO CORRECT THE WIPER MOTOR FAILURE BECAUSE IT'S TOO EXPENSIVE FOR ME; GENERAL MOTORS SHOULD FIX THIS SERIOUS PROBLEM BEFORE SOMEONE GET KILLED. *TR

Oct 05, 2010

Crash: 1

WE NOTICED THAT THE DRIVER'S SIDE MIRROR OF MY WIFE'S 2001 TAHOE APPEARED TO HAVE A MELTED PLACE ON THE BOTTOM OF THE PLASTIC HOUSING. THERE WAS A GREEN/YELLOW CIRCLE IN THE CENTER OF THE MIRROR WHERE IT APPEARED TO HAVE GOTTEN TO HOT. I REMOVED THE MIRROR WHICH WAS CONNECTED BY FOUR WIRES. TWO WIRES WENT TO THE HEATING ELEMENT AND THE OTHER TWO CONTROLLED THE AUTOMATIC DIMMING FEATURE. ON THE INSIDE OF THE DIMMING FEATURE WIRES THERE APPEARED TO BE BLACK RESIDUE. YOU COULD CLEARLY SEE THAT THE MOLDED PLASTIC ON THE BACK OF THE MIRROR HAD MELTED ALONG THE OUTSIDE EDGE (DIGITAL PICTURES AVAILABLE IF NEEDED). I CALLED THE DEALER AND ORDERED A MIRROR THAT ONLY HAD THE HEATED FEATURE WITHOUT THE DIMMING EFFECT. I INSTALLED THIS ON THE LOGIC THAT I COULD LEAVE THE DEFECTIVE WIRES DISABLED. SO FAR EVERYTHING SEEMS TO BE WORKING JUST FINE. THE PRICE OF THE REPLACEMENT WAS $35.00 (HEATER ONLY) AND IF I HAD ORDERED THE DIMMING FEATURE WITH IT ($267.00) "WHICH I THINK IS RIDICULOUS". EVEN THOUGH I WAS OUT THE EXPENSE AND TIME SPENT FIXING THE MIRROR MY HOPE IS THAT YOU CAN RESEARCH THIS AND POSSIBLY KEEP SOMEONE ELSE'S VEHICLE FROM THE POTENTIAL OF BURNING UP OR WORSE YET BURNING UP IN THERE GARAGE AND CATCHING THERE HOUSE ON FIRE. *JB

Dec 03, 2005

ELECTRICAL: IF KEY IS TURNED TO ACCESSORY; AFTER APPROXIMATELY 10 MINUTES THE BATTERY IS DRAINED AND CAR WILL NOT START. THIS HAS BEEN GOING ON FOR 3 YEARS EVEN WITH A NEW BATTERY REPLACEMENT. ALSO, FREQUENTLY THE CLOCK DISPLAY WILL BE ON THE WRONG TIME AND LIGHTS FLICKER WHEN USING THE POWER WINDOWS.*AK

Jan 21, 2004

SERVICE BRAKES, ELECTRIC

2 complaints

I HAVING A PROBLEM WITH MY 2001 CHEVY SUBURBAN 1500 REGARDING THE ABS BRAKE MODULE CONTROL THAT FAILED, AFTER RESOURCE ITS LOOKS LIKE MANY THOUSAND OF 2000-2002 HAVE THE SAME PROBLEM , I CALL GM AND THEY SAYING THEIR IS NO RECALL. IF YOU CHECK THAT ISSUE WOULD YOU THINK IT SHOULD BE A RECALL ? [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Sep 05, 2010

INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) THE ABS COMPUTER ON MY 2001 CHEVROLET SUBURBAN FAILED AT JUST OVER 70,000 MILES. I CONTACTED CHEVY ABOUT THIS AND WAS TOLD IT OCCURRED OFTEN AND THAT IT WASN'T COVERED.. I HAVE SEARCHED THE INTERNET AND HAVE FOUND NUMEROUS OTHER COMPLAINTS ABOUT THIS SAME ISSUE AND EVERYONE THINKS IT SHOULD BE A SAFETY RECALL ISSUE. CAN YOU PLEASE INVESTIGATE THIS AND GET BACK IN TOUCH WITH ME? [XXX] *TR

Jun 07, 2010

POWER TRAIN,EQUIPMENT

2 complaints

I PURCHASED A 2001 CHEVROLET SUBURBAN IN LATE 2005. WE ARE CURRENTLY ON OUR THIRD TRANSMISSION WITH THIS VEHICLE. THE FIRST ONE LOCKED UP AT 20 M MILES AND WAS REPLACED UNDER WARRANTY. THE SECOND FAILED AT ABOUT 98 M AND COST US ABOUT $2500 TO REPLACE AS GM ONLY OFFERED A 1 YR. WARRANTY ON REPLACEMENT TRANSMISSIONS AT THAT TIME. I'M ALREADY CONCERNED ABOUT THE THIRD TRANSMISSION AS IT OCCASIONALLY HAS TROUBLE DROPPING INTO FIRST UPON STOPPING. I THINK GM HAS A PROBLEM HERE THAT THEY ARE FAILING TO OWN UP TO. MY ONLY CONSOLATION IS THIS TRANSMISSION HAS A THREE YEAR WARRANTY.*JB

Mar 11, 2006

TRANSMISSION HAS NOT BEEN SHIFTING CORRECTLY FOR A LONG TIME. BECAME VERY NOTICEABLE IN JULY OF 2001. REAR AIR SOMETIMES DOES NOT TURN OFF WHEN IGNITION IS OFF. FRONT AIRS SOMETIMES CUTS SELF OFF AND BEGINS TO BLOW WARM AIR. ALTHOUGH NOT APPLICABLE. THE DEALERSHIP HAS CHANGED OUT FRONT AND MIDDLE SEAT COVERS FROM CRACKING PROBLEM I TALKED WITH GM AND THEY ADVISED THE DEALERSHIP TO CORRECT THESE SINCE I DO STILL HAVE A WARRANTY. I AM STILL UNSATISFIED WITH THE PERFORMANCE OF MY VEHICLE. THIS IS THE 3RD SUBURBAN I HAVE OWNED. THE OTHER 2 WERE GMC'S. I NEVER HAD A PROBLEM OF THIS NATURE BEFORE. THIS ONE HAS BEEN ANNOYING WITH SMALL PROBLEMS SINCE DAY ONE! DT

Oct 30, 2002

TRAILER HITCHES

2 complaints

TRAILER HITCH FAILURE: DEFECTIVE WELDS AT KEY ATTACHMENTS POINTS BETWEEN RECEIVER TUBE AND CROSSMEMBER ALLOWED GUSSET PLATES TO SHEAR UNDER LATERAL LOAD, CAUSING RECEIVER TUBE TO ROTATE 30 DEGREES OFF CENTER. DETACHMENT FROM VEHICLE AND LOSS OF TRAILER WAS IMMINENT WHEN CONDITION WAS NOTICED.*AK

Sep 08, 2003

THE TRAILER HITCH WELDS BROKE LOSE WHILE TOWING A TRAILER IN I 80 IN OMAHA , NE , THE TRAILER OVERTURNED AND THE SUBURBAN. GENERAL MOTORS REFUSES TO INVESTIGATE THE CASE BECAUSE I HAD SETTLED WITH THE INSURANCE COMPANY, BOLTS CAME LOOSE AND THE WELDS BROKE. CAUSING THE TRAILER TO SWING AND CRASH.*AK

Jan 06, 2002

Crash: 1

SUSPENSION,SERVICE BRAKES, HYDRAULIC,PARKING BRAKE,ENGINE AND ENGINE COOLING,SEATS

2 complaints

# 1. THE DAY AFTER I FIRST PUCHASED AND PICKED UP MY VEHICLE IT SMOKE US OUT OF THE PARKING GARAGE ON OUR VACATION IN OCEANSIDE, CA. #2 THE BRAKES WERE VERY SPONGY AND NOT ANYTHING LIKE THE ONE I DEMOED WHEN I FOUND THIS VEHICLE. I ALMOST HAD AN ACCIDENT ON ROUTE TO OCEANSIDE. THE LAST TWO TRIPS IN THIS HAS NOT BEEN FIXED AND I HAD TO RENT A CAR AGAIN. # 3 ABOUT THE 3 RD. DAY INTO OUR NEW VEHICLE I NOTICED THE PARKING BRAKE WOULDN,T ALWAYS HOLD THE VEHICLE, EVEN AFTER PUTTING IT IN GEAR, WITH THE BRAKE FULLY APPLIED IT WOULD FAIL BUT NOT ALL THE TIME. # 4 AFTER REPORTING THE SMOKING PROBLEM, (STILL ON-GOING) I HAD A NO OIL PRESSURE WARNING AND NOTICE THE GAGE DIDN'T RESPOND FOR ABOUT 10 SECONDS AFTER STARTING THE ENGINE, THEN I HAD PRESSURE BUT A CONSTANT LOW OIL WARNING KEPT APPEARING ON THE MESSAGE CENTER. THIS IS WHEN IT ONLY HAD 1400 MILES ON IT. I NOTICED SOME OIL SPOTS FORMING WHERE I PARKED, I CRAWLED UNDER NEAR THE RIGHT REAR SIDE OF THE MOTOR TO FIND OIL DRIPPING FROM THE ENGINE AND OFF THE SUSPENSION NEAR THE ENGINE. ITS NOW BEEN IN 3 TIMES FOR SMOKING, LEAKS AND VARIOUS OTHER ENGINE NOISES (LIFTERS, RIGHT BANK). # 5 THE VEHICLE HAS PULLED TO THE RIGHT SINCE NEW. I CALLED THEM, THEY SAID WAIT TILL YOU GET A FEW MILES ON IT SO EVERYTHING BREAKS IN. WRONG ANSWER. I CHECKED THE TIRE PRESSURE. IT WAS UNEVEN ON ALL TIRES, MIND YOU THEY WERE SUPPOSED TO CHECK THIS BEFORE I PURCHASED THE VEHICLE. AVERAGE PSI 30, SHOULD BE 40-44PSI COLD. IT HELPED BUT STILL PULLED TO THE RIGHT. AT 5000 MILES I PERSONALLY ROTATED THE TIRES, THIS STILL DIDN'T FIX IT. UPON BRINGING IT IN FOR ALL THE FORMENTIONED AND LAST PROBLEM WHICH BY THE WAY REQUIRED RENTING A CAR TWICE THEY FINALLY TOOK A LOOK AT IT AND KNOW IT PULLS TO THE LEFT AND THE STEERING WHEEL IS NO LONGER LEVEL. # 6 THE RIGHT BUCKET SEAT WON'T LOCK IN AT THE HINGE POINT PROPERLY. THEY SAID THERE WAS A FIX COMING FOR THE ENGINE AND THE SEAT FROM THE FACTORY BUT AS OF YET NOTHING FROM CHEVY OR THE DEALERSHIP.*AK

Sep 25, 2001

# 1. THE DAY AFTER I FIRST PUCHASED AND PICKED UP MY VEHICLE IT SMOKE US OUT OF THE PARKING GARAGE ON OUR VACATION IN OCEANSIDE, CA. #2 THE BRAKES WERE VERY SPONGY AND NOT ANYTHING LIKE THE ONE I DEMOED WHEN I FOUND THIS VEHICLE. I ALMOST HAD AN ACCIDENT ON ROUTE TO OCEANSIDE. THE LAST TWO TRIPS IN THIS HAS NOT BEEN FIXED AND I HAD TO RENT A CAR AGAIN. # 3 ABOUT THE 3 RD. DAY INTO OUR NEW VEHICLE I NOTICED THE PARKING BRAKE WOULDN,T ALWAYS HOLD THE VEHICLE, EVEN AFTER PUTTING IT IN GEAR, WITH THE BRAKE FULLY APPLIED IT WOULD FAIL BUT NOT ALL THE TIME. # 4 AFTER REPORTING THE SMOKING PROBLEM, (STILL ON-GOING) I HAD A NO OIL PRESSURE WARNING AND NOTICE THE GAGE DIDN'T RESPOND FOR ABOUT 10 SECONDS AFTER STARTING THE ENGINE, THEN I HAD PRESSURE BUT A CONSTANT LOW OIL WARNING KEPT APPEARING ON THE MESSAGE CENTER. THIS IS WHEN IT ONLY HAD 1400 MILES ON IT. I NOTICED SOME OIL SPOTS FORMING WHERE I PARKED, I CRAWLED UNDER NEAR THE RIGHT REAR SIDE OF THE MOTOR TO FIND OIL DRIPPING FROM THE ENGINE AND OFF THE SUSPENSION NEAR THE ENGINE. ITS NOW BEEN IN 3 TIMES FOR SMOKING, LEAKS AND VARIOUS OTHER ENGINE NOISES (LIFTERS, RIGHT BANK). # 5 THE VEHICLE HAS PULLED TO THE RIGHT SINCE NEW. I CALLED THEM, THEY SAID WAIT TILL YOU GET A FEW MILES ON IT SO EVERYTHING BREAKS IN. WRONG ANSWER. I CHECKED THE TIRE PRESSURE. IT WAS UNEVEN ON ALL TIRES, MIND YOU THEY WERE SUPPOSED TO CHECK THIS BEFORE I PURCHASED THE VEHICLE. AVERAGE PSI 30, SHOULD BE 40-44PSI COLD. IT HELPED BUT STILL PULLED TO THE RIGHT. AT 5000 MILES I PERSONALLY ROTATED THE TIRES, THIS STILL DIDN'T FIX IT. UPON BRINGING IT IN FOR ALL THE FORMENTIONED AND LAST PROBLEM WHICH BY THE WAY REQUIRED RENTING A CAR TWICE THEY FINALLY TOOK A LOOK AT IT AND KNOW IT PULLS TO THE LEFT AND THE STEERING WHEEL IS NO LONGER LEVEL. # 6 THE RIGHT BUCKET SEAT WON'T LOCK IN AT THE HINGE POINT PROPERLY. THEY SAID THERE WAS A FIX COMING FOR THE ENGINE AND THE SEAT FROM THE FACTORY BUT AS OF YET NOTHING FROM CHEVY OR THE DEALERSHIP.*AK

Sep 25, 2001

SERVICE BRAKES,FUEL/PROPULSION SYSTEM

1 complaint

FUEL PUMP MAY FALTER OR FAIL; FUEL PUMP RELAY WAS NON-FUNCTIONAL, REPLACED IT; OTHER FUSES PASSED TESTING WITH METER; VEHICLE STARTED, WOULD NOT RUN MORE THAN A FEW MINUTES. NEW FUEL FILTER. GUY AT SERVICE STATION BANGED ON GAS TANK, AND IT WOULD START THEN RUN GREAT FOR A MINUTE, THEN WILL NOT RESTART. ORDERING A REPLACEMENT FUEL PUMP. BOUGHT THIS VEHICLE IN 2005 ABOUT THE TIME OF GM RECALL 05027. IN DOING ONLINE TROUBLE-SHOOTING TODAY, I DISCOVERED THE 2001 GM RECALL 05027. HAVE HAD THIS PROBLEM SEVERAL TIMES. FUEL FILTER WAS LAST CHANGED IN JULY 2009. COMPLETE FAILURE WHEN IN MOTION, BACKING OUT OF SERVICE STATION ONTO MAIN STREET (US 64 BUS), JUST INCHES FROM LANE OF TRAVEL (6.14.19).WHAT COULD BE WORSE THAN FUEL PUMP FAILURE AT A BUSY INTERSECTION DURING LUNCH HOUR? GRATEFUL IT DIDN'T CATCH FIRE, OR GET HIT. AS THE SERVICE ATTENDANT TRIED TO RESTART IT, OVER AND OVER, THE RELAY IN THE ECU MAY HAVE FAILED AT THAT TIME. IN THE INTERIM, MY HUSBAND DIED. I REPLACED RELAY/FUSES TODAY 9/14/19, AND VEHICLE STARTED, BUT WOULD NOT STAY RUNNING. ANOTHER MECHANIC BANGED ON FUEL TANK, IT RAN FOR A WHILE, SO HE ADVISED REPLACING PUMP, WHICH IS NOT ROCKET SCIENCE AFTER VIEWING YOUTUBE HOW-TO VIDEOS. WITH THE PUMP FAILING SPORADICALLY, AND RESPONDING TO THE VIBRATION OF BEING BANGED, IT SEEMS LIKE FAULTY WIRING OR CONNECTION PROBLEM, OR THAT SOMETHING IS LOOSE OR NOT FULLY SEATED ANYMORE. LOTS OF FOLKS SAY THE CHEVY 1500 IS WIDELY KNOWN FOR FUEL SUPPLY PROBLEMS. GAS GAUGE HAS NOT BEEN ACCURATE EVER. WHEN FULL, IT MAY SHOW EMPTY WHEN TURNING OR HITTING A SLIGHT BUMP IN THE ROAD. (TRACK BY COMPUTING MPG AND MILEAGE, TO DETERMINE RANGE). IN SHORT DISTANCES, IT SWINGS FULL-> EMPTY->FULL. WIRING DIAGRAM SHOWS TINY FUSE LABELED PRIME, NONE THERE. ABS INDICATOR LIGHTS UP BECAUSE SENSOR CABLE AT RIGHT FRONT TIRE MAY FAIL ON LEFT TURN, OR HARD RIGHT TURN, YET BRAKES ARE FINE.

Sep 16, 2019

SUSPENSION,SERVICE BRAKES

1 complaint

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. WHILE DRIVING AT LOW SPEEDS, THE VEHICLE EXPERIENCED INCREASED STOPPING DISTANCE WHEN BRAKING. THE VEHICLE WAS TAKEN TO COMMONWEALTH CHEVROLET (155 MARSTON ST, LAWRENCE, MA 01841, (978) 687-3000) WHERE IT WAS DIAGNOSED THAT THE DRIVER AND PASSENGER SIDE WHEEL BEARING ASSEMBLIES NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V379000 (SERVICE BRAKES, HYDRAULIC). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 210,000.

Nov 28, 2018

WHEELS,ENGINE

1 complaint

TL* THE CONTACT OWNED A 2001 CHEVROLET SUBURBAN. WHILE DRIVING AT AN UNKNOWN SPEED, SMOKE EMITTED FROM THE ENGINE COMPARTMENT OF THE VEHICLE. THE CONTACT PULLED OVER AND DISCOVERED THAT THE FRONT END AND FRONT WHEELS WERE ON FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. FIRE AND POLICE REPORTS WERE FILED. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO A SALVAGE YARD AND DEEMED DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 204,654.

Oct 17, 2016

Fire: 1

STEERING,ENGINE

1 complaint

EXHAUST BOLTS BROKEN AND CAUSING A LEAK MAKING THE VEHICLE UNABLE TO PASS EMISSIONS ALSO. STEERING STABILIZERS BROKEN.

Dec 13, 2015

Crash: 1

Injuries: 2

ELECTRICAL SYSTEM,UNKNOWN OR OTHER

1 complaint

DRIVING ON HIGHWAY AT 75MPH BATTERY, SECURITY AND LOW FUEL POPPED ON INTO MESSAGE CENTER. GAS GAUGE, VOLT METER, AND TEMPERATURE GAUGE QUIT WORKING, HAD TO PULL OFF THE SIDE OF THE HIGHWAY BECAUSE OF IT ALMOST GOT HIT. I KNOW NUMEROUS PEOPLE WITH SAME ISSUE.

Aug 11, 2015

ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

1 complaint

WENT TO START MY 2001 CHEVY SUBURBAN AND IT WOULDN'T START. I LISTENED FOR THE FUEL PUMP TO ENGAGE AND IT WASN'T WORKING. I CHECKED THE RELAY AND NOTICED IT WAS MELTED ON ONE CORNER. I HAVE RESEARCHED THIS ONLINE AND FOUND SEVERAL COMPLAINTS ABOUT THE SAME PROBLEM. ALSO NOTICED THAT GM HAS DONE NOTHING TO FIX THIS ISSUE. I HAVE BEEN A GM FAN ALL MY LIFE AND WOULD LIKE TO CONTINUE BEING ONE. PLEASE RECALL THIS ON GOING PROBLEM GM. *TR

Jan 29, 2015

POWER TRAIN,SERVICE BRAKES,FUEL/PROPULSION SYSTEM

1 complaint

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THAT THE VEHICLE WAS SHIFTED INTO DRIVE AND THE VEHICLE FAILED TO MOVE FORWARD. THE CONTACT ALSO STATED THAT THE BRAKE WARNING LIGHT ILLUMINATED. ON ANOTHER OCCASION WHILE DRIVING AT APPROXIMATELY 5 MPH, THE ENGINE STALLED WITHOUT WARNING. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE MECHANIC ALSO STATED THAT THE ANTI LOCK BRAKE SYSTEM FAILED AND UNKNOWN PARTS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED FOR THE ANTI LOCK BRAKE SYSTEM FAILURE BUT THE FUEL PUMP WAS NOT REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 05V379000 (SERVICE BRAKES, HYDRAULIC) AND 05V155000 (FUEL SYSTEM, GASOLINE). THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

Dec 02, 2014

ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

THE BOLTS THAT HOLD THE EXHAUST MANIFOLDS DOWN ARE BREAKING OFF AT THE HEADS AND CAUSING EXHAUST LEAKS. WHICH ARE IN TURN CAUSING MY CATALYTIC CONVERTERS FAIL PREMATURELY. I HOPE GM FIXES THIS MASSIVE PROBLEM WITH THERE LS V8 ENGINES! *TR

Feb 12, 2014

ELECTRICAL SYSTEM,ENGINE

1 complaint

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE VEHICLE FAILED TO START WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE CAME SHAFT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED BECAUSE THE REPLACEMENT PART WAS NOT READILY AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 124,000. UPDATED 04/15/14 MA

Dec 02, 2013

ENGINE AND ENGINE COOLING,POWER TRAIN

1 complaint

I JUST FIX MY HEAD GASKET FROM LEAKING 2 WEEKS LATER THE TRANSMISSION GAVE OUT A WEEK LATER THE SENSOR GAVE OUT THEN THE OTHER SENSOR KNOCK SENSOR 2 THEN THE SENSOR PUMP GAVE OUT TOO WITH IN 6 MONTHS AND COST ME ABOUT 4000 AFTER TAX CHEVY. *TR

Aug 04, 2012

SERVICE BRAKES, HYDRAULIC,FUEL SYSTEM, GASOLINE

1 complaint

TL*THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. THE CONTACT STATED THAT AFTER RECEIVING A RECALL NOTICE IN REFERENCE TO NHTSA CAMPAIGN ID NUMBER 05V379000 (SERVICE BRAKES, HYDRAULIC:ANTILOCK) AND FOR 05V155000(FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP). THE FIRST RECALL REPAIRED THE FAILURE THAT OCCURRED SEVEN MONTHS LATER WHEN THE ABS LIGHTS ILLUMINATED ON THE INSTRUMENTAL PANEL. THE VEHICLE WAS INSPECTED BY THE DEALER WHO STATED THAT HE NEEDED TO REPLACE THE BRAKING MODULE AND THE EBCM. THE VEHICLE WAS REPAIRED. THE SECOND RECALL NOTICE WAS ISSUED THE FAILURE OCCURRED LATER IN 2010 WHEN THE VEHICLE STALLED WHILE DRIVING AT VARIOUS SPEEDS. THE VEHICLE WAS INSPECTED BY A DEALER WHO ADVISED HIM THAT THE FUEL PUMP AND THE FUEL FILTER NEEDED TO BE REPLACED. THE FUEL PUMP AND FILTER WERE REPAIRED. THE FAILURE MILEAGES WAS APPROXIMATELY 120,600. UPDATED 03/24/11*LJ UPDATED 04/28/11

Feb 15, 2011

SERVICE BRAKES, ELECTRIC,EQUIPMENT

1 complaint

OUR 2001 CHEVROLET SUBURBAN IS EXPERIENCING BRAKE PROBLEMS WHICH WERE SUPPOSED TO BE FIXED DURING A 2005 RECALL OF THE VEHICLE. THE CAR IS EXPERIENCING A SUDDEN ACTIVATION OF ANTI-LOCK BRAKES AS DESCRIBED IN RECALL # 05068. I HAVE BEEN TOLD BY GM TO BASICALLY FIX IT OUT OF MY OWN POCKET WHICH I FIND HARD TO BELIEVE SINE THEY HAVE HAD RECALL ISSUES WITH THE SAME PROBLEM. *TR

Dec 08, 2010

ELECTRICAL SYSTEM,SEATS

1 complaint

WHILE BACKING OUT OF DRIVEWAY, OUR 2001 CHEVY SUBURBAN 1500 BEGAN SMOKING FROM UNDER THE DRIVER'S SEAT. AS I PARKED TO INVESTIGATE, FLAMES BEGAN TO CAME OUT FROM UNDER THE SEAT AND I PUT OUT THE FIRE WITH A WATER HOSE. THE FIRE SEEMS TO INITIATE FROM THE WIRING FOR THE SEAT CONTROL. LEFT MINOR DAMAGE UNDER THE SEAT, BURNT RUG AND WATER LOG FROM PUTTING THE FIRE OUT. INSURANCE COMPANY TO FOLLOW UP INVESTIGATION. *TR

Nov 14, 2010

Fire: 1

STEERING,FUEL SYSTEM, GASOLINE

1 complaint

MY 2001 SUBURBAN COMPLETELY SHUTS OFF AND THE STEERING STOPS WHEN I AM AT SPEEDS BELOW 10 MPH, IF I AM MAKING A TURN, BACKING OUT OF MY DRIVEWAY, OR COME TO A STOP AT A STOP SIGN. I TOOK IT TO MANY PLACES TO HAVE IT TESTED AND THEY ALL STATED THAT EVERYTHING IS FINE NOTHING WAS DETECTED. I HAVE HAD THE FUEL PUMP REPLACED BY DEALERSHIP WHEN IT JUST COMPLETELY STOPPED RUNNING ON THE HIGHWAY. I AM AT A LOSS FOR WORDS AND THIS IS DANGEROUS WHEN IT IS THE ONLY CAR YOU HAVE TO HAUL YOURSELF AND KIDS AROUND IN. THIS IS HAPPENING EVERYDAY AND IT SEEMS THAT I AM NOT THE ONLY ONE HAVING THIS PROBLEM. THIS IS A SERIOUS PROBLEM FOR AMERICANS TRYING TO MAKE AN HONEST LIVING. *TR

Mar 02, 2010

ELECTRICAL SYSTEM,TIRES

1 complaint

2001 CHEVY SUBURBAN 8.1 WHEN DRIVING AT ALL SPEEDS JUST DIES. STARTS BACK UP 5-15MINS. REALLY SCARY IF YOUR DOING 75 MPH IN HEAVY TRAFFIC. I AM 99% SURE ITS THE CRANKSHAFT SENSOR. GM HAS A RECALL ON 2001 2500 HD TRUCKS ONLY!!!!I FOUND OUT ABOUT THE CRANKSENSOR FROM SOME PEOPLE ONLINE WHO LEARNED THE HARD WAY .WITH TODAY TIMES PEOPLE CANT AFFORD TO PAY BIG BUCKS FOR LITTLE PARTS. GM NEEDS TO EXTEND THE RECALL TO ALL 8.1 L REGARDLESS OF YEAR OR MAKE. I FOUND A WEB SITE THAT SOME BOAT MOTORS ARE DOING THE SAME THING 8.1 GM. CHEAP IF YOU FIX IT BEFORE YOUR OUT ON A ROAD TRIP. P.S. I HEARD ABOUT A OPENING ON THE HUMP BUT GM LINE WELDED IT UP. *TR

Apr 07, 2009

STEERING,SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING

1 complaint

TL*THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. WHILE DRIVING 70 MPH, THE VEHICLE WOULD RANDOMLY SHUT OFF AND COMPLETELY STOP. THE OTHER COMPONENTS, SUCH AS THE RADIO, WERE STILL OPERABLE. THE POWER STEERING AND BRAKES WERE ALWAYS AFFECTED AND WOULD BECOME INOPERABLE. OCCASIONALLY, THE VEHICLE IMMEDIATELY RESTARTS AND OTHER TIMES, THE CONTACT MUST WAIT A COUPLE OF MINUTES. THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 07V521000 (ENGINE AND ENGINE COOLING). THE DEALER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 59,000.

Jan 12, 2009

SERVICE BRAKES, HYDRAULIC,ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

ABS RECALL 05068, CLEAN & INSPECT WHEEL SENSORS, 18 NOV 2005. ABS & TRACTION CONTROL WARNING LIGHTS ON,16 JUN 2006 (55977 MILES). DEALER DIAGNOSTIC CODE C0265, ECBM ($925.59 PART) AND ALSO BPMV ($761.14 PART) PLUS APPROX 2HRS LABOR. I ASKED IF IT WOULD BE SAFE TO DISCONNECT THE PUMP FROM THE ABS SYSTEM UNTIL I COULD SEE IF THE RECALL WOULD COVER THIS COST, IT HASN'T HAPPENED AS OF THIS DATE. THE VEHICLE HAS BEEN IN OPERATION SINCE THIS SYSTEM FAILURE. I NOW HAVE LEARNED THAT THE RELAY ON THE EBCM THAT CONTROLS THE POWER HAS CONTACTS THAT WELD CLOSED WHICH CAUSES THE PUMP TO RUN CONTINUOUSLY. I ASKED IF I COULD HAVE THE OLD PART WHEN I GET IT FIXED AND WAS TOLD NO BECAUSE IT MUST BE RETURNED. I ALSO FEEL THAT WHEN I WAS TOLD IT MAY ALSO NEED THE BPMV THAT THE CHECK VALVE HOLDING THE PUMP PRESSURE COULD BE THE TRUE CAUSE OF SYSTEM FAILURE. I FEEL THAT PEOPLE THAT BUY THIS SAFETY FEATURE SHOULD HAVE IT WORK FOR THE LIFE OF THE VEHICLE. I ALSO KNOW THAT THE REPAIR COSTS HAVE SINCE GONE UP. *TR

Jul 18, 2008

SERVICE BRAKES, HYDRAULIC,POWER TRAIN,EXTERIOR LIGHTING

1 complaint

TL*THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. WHILE DRIVING 35 MPH IN THE RAIN, THE ABS LIGHT ILLUMINATED. WHEN THE CONTACT TURNED OFF THE ENGINE, IT MADE A HUMMING SOUND. HE DISCONNECTED THE MODULE AND THE HUMMING STOPPED. THE CONTACT TOOK THE VEHICLE TO THE DEALER THE FOLLOWING DAY AND THEY REPLACED THE MODULE UNDER WARRANTY. THREE YEARS LATER, THE FAILURE RECURRED. HE PURCHASED THE THIRD MODULE AND HAD IT REPLACED BY A LOCAL MECHANIC. THREE WEEKS AGO, THE CONTACT NOTICED THAT THE TURN SIGNALS ON HIS VEHICLE WERE INTERMITTENTLY ILLUMINATING. AS OF JUNE 12, 2008, THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND CURRENT MILEAGE WAS 80,000. UPDATED 07/08/08. *BF THE CONSUMER ALSO STATED THERE WAS A DELAYED ENGAGEMENT FROM REVERSE TO DRIVE. UPDATED

Jun 12, 2008

ELECTRICAL SYSTEM,EQUIPMENT

1 complaint

MY 2001 CHEV SURBAN CAUGHT ON FIRE IN MY GARAGE WHEN CAR WAS NOT RUNNING. WHILE PICKING UP MY DAUGHTER FROM SCHOOL MY ABS WARNING LIGHT CAME ON --I RETURNED HOME WITHIN 5 MINS AND WITH 10 MINS MY CAR WAS ON FIRE. --DEALERSHIP THAT I BOUGHT THE CAR FROM AND HAVE HAD SERVICED THERE HAS MY CAR. I HAVE BEEN TRYING TO DEAL WITH THEM AND IT HAS BEEN A COMPLETE NIGHTMARE. THE SAFTEY OF MY FAMILY IS AT RISK IF I CONTIUNE TO DRIVE THE CAR---THEY DONT KNOW IF THAT WILL HAPPEN AGAIN OR NOT THEY SAY. AT FIRST THEY SAID IT WOULD COST $2,000 TO FIX THE CAR --REPLACE PARTS THAT WERE DAMAGED FROM THE FIRE--AFTER I STARTED ASKING IF GENERAL MOTORS SHOULD BE RESPONSIBLE THEY SAID THEY WOULD ONLY CHARGE ME $950.00 SINCE I WAS A GOOD CUSTOMER. I EXPLAINED TO THEM THERE MUST BE A DEFECT IN THE CAR---MY CAR IS IN EXCELLENT CONDITION---2001 70,000 MILES AND HAS BEEN SERVICED EVERY 3,000 MILES. THEY SAID THEY HAVE NEVER SEEN THIS BEFORE. THEN THEY SAID GENERAL MOTORS WILL PAY TO HAVE THE PARTS REPLACED THAT WERE DAMAGED AND PUT IN A NEW ABS MODULE, AND THAT I SHOULD BE OKAY. I CANT RISK THE SAFTY OF MY FAMILY AND MY HOUSE TO PARK THE CAR IN THE GARAGE AND CONTUINE TO DRIVE IT.. I WOULD APPREICATE ANY HELP OR ADVISE THAT YOU MIGHT HAVE FOR ME.

May 30, 2008

Fire: 1

STEERING,AIR BAGS

1 complaint

NOVEMBER 2004 I HAD AN AUTO ACCIDENT, I WAS DRIVING HOME LATE AT NIGHT AFTER MY HUSBAND AND I HAD BEEN OUT TO DINNER WITH A FRIEND ON LEAVE FROM THE MILITARY. WE WERE ON THE WAY TO PICK OUR KIDS UP FROM MY PARENTS AND IT WAS MISTING OUTSIDE. I WAS ON A 4 LANE HIGHWAY TRAVELING SOUTHBOUND ON THE FAR INSIDE LEFT HAND LANE, THE NEXT THING I KNEW I WAS FACING THE POLICE STATION HEAD-ON AT 35 MPH. I TRIED TO CORRECT THE WHEEL AND MY HUSBAND ALSO GRABBED THE WHEEL AND TRIED TO CORRECT IT, DIDN'T WORK I THINK THE WHEEL BROKE BECAUSE WE CRASHED INTO THE POLICE STATION. I HAD TO KICK MY DOOR OPEN AND RUN INSIDE TO HAVE THEM CALL AN AMBULANCE, MY HUSBAND WAS PINNED AGAINST THE WALL, HIS FACE BUSTED THE PASSENGER WINDOW OUT, AND THE DASH,THE RADIO AND GLOVE BOX WAS IN OUR LAP AND THE WINDSHIELD SHATTERED. WE WERE WEARING SEATBELTS AND THE FRONT AND SIDE WAS TOTALED BUT THE AIR BAGS DID NOT DEPLOY. THE ONLY WORKING DOORS WERE THE BACK HATCH AND THE REAR DRIVER SIDE DOOR, THE PASSENGER DOOR WAS CAVED IN ON MY HUSBAND AND HE WAS FORCED ACROSS THE CONSOLE HE HAD TO BE PULLED FROM THE AUTO. HE WAS TRANSPORTED TO THE ER AND ENDED UP MISSING WEEKS OF WORK FROM HIS INJURIES , I REFUSED TREATMENT WITH ONLY MY KNEE AND FOOT HURT. I WAS FOUND NOT AT FAULT AND NO TICKECTS WERE WROTE. WE HAD BEEN HAVING FRONT END PROBLEMS THAT CHEVY MECHANICS AND OTHER MECHANICS COULD NOT EXPLAIN. YES THEY SAW AND HEARD THE PROBLEM BUT DIDN'T KNOW HOW OR HAVE A WAY TO FIX IT,I BELIEVE THAT IS WHY WE CRASHED SOMETHING WITH THE FRONT END. I REPORTED TO THE POLICE THAT MY HUSBAND GRABBED THE WHEEL TRYING TO CORRECT IT BUT THEY WROTE IT AS HE GRABBED ME CAUSING THE WRECK; NEEDLESS TO SAY I CORRECTED THE ERROR BUT THEY DIDN'T CORRECT THEIR REPORT. I CONTACTED CHEVY ABOUT THE INCIDENT AND WANTED TO KNOW WHY MY AIRBAGS DIDN'T DEPLOY, THEY CALLED ME ON A SUNDAY BUT NOTHING WAS EVER DONE. *CN

Jan 05, 2008

Crash: 1

Injuries: 2

STEERING,SUSPENSION,POWER TRAIN,VISIBILITY,AIR BAGS

1 complaint

NUMEROUS THINGS HAVE GONE WRONG WITH MY 2001 MONTE CARLO. 5 OR 6 TIMES THE DEALERSHIP HAS REPAIRED THE DRIVER SIDE AIRBAG WHERE IT CONTINUALLY POPS OUT. I AM REALLY CONCERNED WHEN IT MIGHT EXPLODE W/O A CRASH OR IF THERE IS A DRIVER SIDE CRASH IF IT WILL COME OUT TO PROTECT ME. STEERING AND FRONT SUSPENSION POPS. AT 55,117 MILES WE HAD THE OIL CHANGED (WHICH HAS BEEN DONE EVERY 3000 MILES) OR LESS AND ON THE MULTI POINT INSPECTION SHEET, IT LISTED SEVERAL THINGS THAT "MIGHT NEED ATTENTION" SOON. THEY ARE STEERING LINKAGE AND STEERING COMPONENTS, CV AXLE BOOTS OR DRIVE SHAFT AND U JOINTS. THESE THINGS SHOULD NOT BE WORN OUT ON A CAR WITH NO MORE MILES THAN THIS. MY REAR WINDOW DEFOGGER DOESN'T WORK. NOTICED THIS AFTER ONE OF THE AIRBAG REPAIRS. THIS CAR HAS BEEN VERY WELL TAKEN CARE OF BUT STILL THE NOISES PERSIST AND NOW TO BE TOLD THAT THESE PARTS MIGHT NEED REPAIR OR REPLACEMENT? WE PAID A LOT OF GOOD MONEY FOR THIS VEHICLE (THIS IS A LIMITED EDITION HIGH SPORT VEHICLE) AND FEEL GM SHOULD BUY IT BACK AND REIMBURSE EVERY DIME OF IT DUE TO THE POOR QUALITY OF IT OR PROPERLY REPAIRED OR PARTS REPLACED AT GM EXPENSE WHILE PROVIDING AN EQUAL VALUE VEHICLE WHILE REPAIR WORK IS DONE. *TR

Sep 28, 2007

SERVICE BRAKES, HYDRAULIC,POWER TRAIN

1 complaint

OUR 4 YEAR OLD CHILD WAS ABLE TO PUT OUR 2001 CHEVY SUBURBAN IN GEAR WITHOUT STARTING THE CAR OR PRESSING HIS FOOT ON THE BRAKE. THE CAR STARTING ROLLING DOWN THE HILL. FORTUNATELY MY WIFE WAS ABLE TO JUMP IN THE WINDOW AND PRESS THE BRAKE TO STOP THE CAR. WE WERE VERY LUCKY THAT NONE OF THE CHILDREN IN THE AREA WERE HURT AND THAT NO PROPERTY WAS DAMAGED OTHER THAN A SMALL PIECE OF FENCE. APPARENTLY WITH THE KEY IN THE IGNITION AND IN THE FIRST "ACCESSORY" POSITION YOU ARE ABLE TO TAKE THE CAR OUT OF PARK WITHOUT DEPRESSING THE BRAKE PEDAL. I TRIED THIS ON SEVERAL OTHER CHEVY MODELS THAT HAVE THE GEAR SHIFT ON THE COLUMN AND YOU ARE ABLE TO DO THE SAME THING. I CALLED CHEVY AND THE DEALER AND THEY BOTH SAID THAT THIS SHOULD NOT HAPPEN AND TO BRING IT IN FOR REPAIR. THE DEALER EVEN WENT TO THE LOT AND DID WHAT I DESCRIBED ON A 2006 SUBURBAN AND AGREED THAT IT DID HAPPEN WHEN HE DID IT. IF THIS IN FACT THE WAY THE CAR IS MANUFACTURED IT WOULD BE NICE IF THEY ACKNOWLEDGED THAT FACT AND PUT IT IN THE OWNERS MANUAL. *TR UPDATED 12/12/2007 *BF THE CONSUMER STATED THE MANUFACTURER IS BEING PHASED OUT, HOWEVER WOULD LIKE TO BE NOTIFIED IF THE OLDER OWNERS WOULD BE NOTIFIED. UPDATED 12/12/07 *TR

Sep 04, 2007

STEERING,EQUIPMENT

1 complaint

I OWN A 2001 CHEVY SUBURBAN WITH 68,000 MILES AND I HAVE HAD TO REPLACE THE POWER STEERING TWICE BECAUSE IT CRACKED IN HALF WHILE I WAS DRIVING. CHEVY SAYS IT WAS MY FAULT. HOW DOES A LADY WHO IS NOT THAT STRONG CRACK TWO POWER STEERING IN HALF WHILE SHE IS DRIVING? *JB

May 13, 2006

Crash: 1

FUEL SYSTEM, GASOLINE,FUEL SYSTEM, OTHER

1 complaint

DT: THERE IS RECALL # 05V155000 FOR THE FUEL MODULE RESERVOIR ASSEMBLY WHERE THE WIRE BREAKS THE SEAL IN THE GAS TANK. CONTACTED THE DEALER. THEY TOOK THE GAS TANK OFF AND THAT THE FUEL MODULE WAS BAD. THE WIRE GOT WARM AND CAUSED A HOLE IN THE CONNECTOR, AND FUEL VAPORS LEAKED OUT, AND ENGINE LIGHT APPEARED ON AUGUST 25, 2005 . THAT WAS WHY I THE CONSUMER TOOK THE VEHICLE TO DEALER. WHEN THE GAS GOT LOW THE GAS GAUGE WOULD GO ALL THE WAY TO AND BACK TO THE ACTUAL AMOUNT OF GAS THAT WAS IN IT. *AK

Sep 14, 2005

VISIBILITY,LATCHES/LOCKS/LINKAGES

1 complaint

DT: CONSUMER OWNS 2001 CHEVROLET SUBURBAN. TWO OF THE ELECTRICAL MOTORS HAD GONE OUT ON THE POWER WINDOWS, TWO SEPARATE WINDOWS. SHE TOOK VEHICLE A GARAGE T TO HAVE WINDOW MOTORS REPLACED , AND THE MECHANIC CALLED THE DEALER FOR PARTS, AND WAS TOLD THAT THE MOTOR WAS ALREADY ON BACK ORDER, SHE SAID THAT THIS SHOWED HER THAT SHE WAS NOT THE ONLY ONE HAVING THIS PROBLEM. ALSO, HAD A PROBLEM WITH ELECTRICAL LOCKS, THEY FAILED. THE DRIVER'S DOOR WILL OPEN AUTOMATICALLY BUT THE OTHER DOORS HAVE TO BE OPENED MANUALLY. THE FRONT DOORS HAD EXTERIOR LOCKS , AND ONE COULD UNLOCK THEM FROM THE OUTSIDE. BUT, THE REAR DOORS DID NOT HAVE EXTERIOR LOCKS. SHE HAD TO REACH THEM FROM THE FRONT TO MANUALLY UNLOCK THE REAR DOORS TO GET IN FROM THE OUTSIDE. *AK

Aug 15, 2005

SUSPENSION,SERVICE BRAKES, HYDRAULIC,STRUCTURE

1 complaint

DT: THE BRAKES AT LOW SPEEDS WERE WORKING POORLY, CAUSING EXTENDED STOPPING DISTANCES. THEY ALSO MADE A THUMPING SOUND WHEN THE ABS SYSTEM FAILED. TOOK VEHICLE TO THE DEALER AND THEY CLAIMED IT WAS OTHER THINGS BESIDES THE ABS SYSTEM. DEALERSHIP WANTED CONSUMER TO SPEND MONEY ON THE BRAKE PADS/ROTORS, AND CALIPERS FIRST AND THEN ON DEFECTIVE WHEEL BEARING. TOOK VEHICLE TO MECHANIC, AND STATED THAT WAS NOT THE PROBLEM HE RECOMMENDED TO THE DEALER, BUT DEALER DID NOT WANT TO FIX THE ACTUAL PROBLEM.*AK THE VEHICLE HAD EXCESSIVE AMOUNTS OF RUST ON IT (FRAME, CALIPERS, ROTORS AND NON-BODY PARTS). THE CALIPERS WERE RUSTED AND LEAKING. THE ROTORS WERE WARPED AND CORRODED AND THE BRAKE PADS WERE WORN AND NEEDED TO BE REPLACED. *NM

Aug 01, 2005

SEAT BELTS,VEHICLE SPEED CONTROL

1 complaint

CONSUMER STATES: SHUTTING ON AND OFF THE IDLE WILL GO LOW AND HIGH AND WILL ITSELF SHUT OFF. HAD WORK DONE TO HAVE IT REPAIRED, BUT ONLY LASTED A COUPLE OF MONTHS. HAD THE SMELL OF GAS. ALSO, SEAT BELTS ON THE SECOND SEATS ARE NOT WORKING PROPERLY. CAN'T PULL THE SEAT BELTS OUT, THEY ARE STUCK INSIDE OF THE WALL OF THE VEHICLE.*AK

May 10, 2005

SERVICE BRAKES, AIR,VISIBILITY

1 complaint

PROBLEM WITH ANTILOCK BRAKES- LONGER STOPPING DISTANCES REQUIRED WHEN BRAKES ARE APPLIED DURING LOW SPEEDS. NO INCIDENT HAS OCCURRED

May 04, 2005

EXTERIOR LIGHTING,ELECTRICAL SYSTEM

1 complaint

THE HORN FUSE KEPT BURNING OUT. CONSUMER TOOK THE VEHICLE TO DEALER, AND NO DFECTS WERE FOUND. LATER, WHILE PARKING IN THE DRIVEWAY, IT STARTED TO BLOW OWN ITS OWN. HEADLIGHTS WENT OFF WHILE BEING DRIVEN, AND CURRENTLY THEY DO NOT WORK AT ALL.*AK

Feb 14, 2005

POWER TRAIN,ELECTRICAL SYSTEM

1 complaint

HEATED POWER MIRRORS WITH DIMMING FEATURE HAS A LIQUID INSIDE THAT HAS TURNED DIRTY BROWN RESTRICTING SIGHT REARWARD. THE POWER SWITCH ADJUSTING THE REARVIEW MIRRORS INOP. CD PLAYER INOP. SUNROOF INOP. SUNROOF GETS STUCK INSIDE ITS RAILS IN OPEN POSITION. UNABLE TO OPEN OR CLOSE. ENGINE LEAVES POLLS OF OIL INSIDE MY GARAGE APPROX 1QT. PR 1000 MILES. JUST HAD A CATASTROPHIC TRANSMISSION FAILURE WITH A VERY CLOSE CALL ACCIDENT, LOOSING 3RD AND 4TH GEAR REQUIRING COMPLETE REBUILD OF TRANSMISSION, DRIVE AXLE LEAKING OIL. AND OF COURSE ALL THIS HAPPENS JUST OUT OF WARRANTY. THIS CAR TODAY COSTS $ 50,000.- WITH THIS TRIM PACKAGE. HAS ONLY 81000 ON ODOMETER. GM THIS IS NOT GOOD ENOUGH, SHAPE UP OR SHIP OUT. THIS IS MY 3RD LEMON FROM GM. DO THEY NOT MAKE CARS THAT'LL LAST PAST WARRANTIES ANY MORE?? *JB

Feb 11, 2005

SUSPENSION,ELECTRICAL SYSTEM,EXTERIOR LIGHTING,VISIBILITY,SEAT BELTS,STRUCTURE,SEATS

1 complaint

WHILE DRIVING OR IDLING THE ELECTRICAL SYSTEM SHUT DOWN INTERMITTENTLY AND CAUSED THE VEHICLE TO STALL. THE VEHICLE WAS TAKEN TO THE DEALER, AND THE DEALER REPLACED THE ELECTRICAL SYSTEM, BUT THE PROBLEM RECURRED. THE DEALER STILL WAS UNABLE TO DETERMINE THE CAUSE OF THE PROBLEM. *AK THE REAR FLOOR PLASTIC PLATE HAD BROKEN, THE LEFT REAR WINDOW MOTOR WAS INOPERATIVE UP AND DOWN, THE DRIVER'S SIDE SEAT WAS COMING APART BY THE DOOR, SEAT TRACK HAD BROKEN, THE RIGHT FRONT SEAT BELT SHOULDER STRAP SOMETIMES TIGHTENED UP, THERE WAS NOISE IN THE REAR END HAD A HARMONIC VIBRATION, THE RIGHT SECOND WINDOW WOULD NOT GO DOWN, THE PASSENGER SIDE SEAT BELT IN THE FRONT LOCKED UP RIGHT FRONT RETRACTOR LOCKED, THE REAR PASSENGER SIDE DOOR SQUEAKS REALLY BAD, THE MOLDING FOR THE RUBBER COMING OFF, AND PASSENGER SIDE FRONT LIGHT HAD COME OUT. *SC

Nov 30, 2004

SERVICE BRAKES, HYDRAULIC,FUEL SYSTEM, OTHER

1 complaint

FUEL LEAKED FROM THE TANK AFTER THE CONSUMER PUT GAS INTO THE VEHICLE. THE DIFFERENTIAL BROKE WHICH CAUSED A GRINDING NOISE. *NM THE VEHICLE WAS TAKEN IN FOR SERVICE AND FOUND THAT THE ELEVTRICAL WIRES AROUND THE NECK OF THE TANK WERE MELTED AND THE TANK HAD TO BE REPLACED. CONSUMER STATED THAT THE SHORT IN THE ELECTRICAL LINES COULD HAVE CAUSE A FIRE. ON A ROAD TRIP THE VEHICLES RIGHT REAR BREAK STARTED GRINDING INTO THE PADS. *TC

Nov 05, 2004

SEAT BELTS,EQUIPMENT

1 complaint

1)FRONT PASSENGER SEAT BELT LOCKS UP. NO ONE WOULD WEAR SEAT BELT DUE TO PROBLEM. MECHANISM REPLACED BY DEALER 4 TIMES, STILL NOT WORKING. DEALER ADED AN EXTENSION TO SEAT BELT AND THAT PREVENTS IT FROM LOCKING. *AK 2)PARKING BRAKE NEVER HELD VEHICLE, STARTED TO GO ALL THE WAY TO THE FLOOR. DEALER STATES THATS NORMAL. TOOK IN AT 15,000 AND 25,000 MILES WITH SAME PROBLEM. AT 37,000 MILES THEY WANT TO CHARGE ME $800.00 TO REPLACE REAR ROTORS AND BRAKE PADS. REFUSED TO PAY THEM FOR REPAIR, TOOK IT TO A TIRE REPAIR SHOP AND PAID $630.00. ROTORS WERE FALLING APART. THIS IS A VERY DANGEROUS SITUATION IT SEEMS THE PARKING BRAKE STAYS ON EVEN WHEN RELEASE. 3) SUDDEN LOSS OF POWER STEERING AND ALL LIGHTS ON DASH GO ON WHILE DRIVING AT ANY SPEED. HEADLIGHTS ALSO DIM OFF AND ON. ALTERNATOR WIRING REPLACED. TWO MONTHS LATER SAME THING, WIRING REPLACED. LEAVE DEALER AND HAPPENS AGIAN ON THE WAY HOME. NOW ALTERNATOR AND WIRING REPLACED.

Oct 04, 2004

ENGINE AND ENGINE COOLING,VISIBILITY

1 complaint

THE VEHICLE DISPLAYED A LOUD NOISE THAT SOUNDED LIKE A MUFFLER AND OR VACUUM. THE VEHICLE WAS TAKEN TO THE DEALER IN WHICH THEY HAD TAKEN DIAGNOSTIC TESTS BUT WASN'T SURE WHAT THE PROBLEM WAS. THEY THEN STATED THAT THERE WAS A KNOWN PROBLEM WITH THE INTAKE SYSTEM IN WHICH AIR WOULD SURROUND THE ENGINE. THE PROBLEM SEEMED TO WORSEN EACH TIME THE VEHICLE WAS IN MOTION. THE RIGHT FRONT WINDOW WAS INOPERATIVE DUE TO THE MOTOR GOING BAD. *AK *SC *JB

Jun 04, 2004

EQUIPMENT

1 complaint

MY VEHICLE SPONTANEOUSLY CAUGHT ON FIRE. THE SMOKE STARTED COMING OUT OF THE CD/RADIO. WITHIN MINUTES THE SMOKE WAS SO THICK THAT OUR EYES WERE BURNING AND IT WAS DIFFICULT TO SEE AND BREATHE. BY THE TIME I GOT THE CAR OVER AND EVACUATED 5 KIDS AND A DOG, FIRE WAS ACTUALLY VISIBLE. THE FLAME WAS COMING OUT OF THE CD PLAYER.*AK

Feb 27, 2004

Fire: 1

Injuries: 6

SERVICE BRAKES, AIR,EQUIPMENT

1 complaint

@2001 CHEVY SUBURAN ABS MODULE WENT OUT AT 33,000 MILES. FIXED UNDER EXTENDED WARRANTY. WENT OUT AGAIN AFTER 35,000 ADDITIONAL MILES DEALER SAYS NOTICE IT HAPPENS ON THIS MODEL CAR BUT NOT RECALLED YET. COST ABOUT 1200 TO FIX. ABS LIGHT COMES ON AND STAYS. CAN HEAR MOTOR RUNNING EVEN WHEN CAR TURNED OFF. DRAINS BATTERY AND CAR WILLNOT START.MODULE HAD TO BE REPLACED BOTH TIMES. SHOULD NOT BE HAPPENING.

Feb 12, 2004

SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING,AIR BAGS

1 complaint

AFTER TAKING MY TRUCK IN FOR A COMPLETE FUEL SYSTEM CLEANING SERVICE, I STARTED TO HEAR A RATTLING SOUND EVERY TIME I TURNED ON THE AC. I TOOK IT BACK TO THE DEALERSHIP (CAPITAL CHEVROLET IN MONTGOMERY, ALABAMA) THINKING THAT THEY FORGOT TO TIGHTEN UP SOMETHING -- ONLY TO FIND OUT I NEED A NEW AC COMPRESSOR. I OVERHEARD THE SERVICE TECHNICIAN SAY THAT THERE IS A BULLETIN OUT ON THIS. I CALLED THE 800# BUT HAVE NOT GOTTEN A RESPONSE IN OVER A WEEK. I WAS TOLD BY 2 INDEPENDENT SERVICE MECHANICS THAT THIS IS A MAJOR PROBLEM WITH THAT THE SUBURBAN AND TAHOE!!! DECEMBER 2002. ATTEMPTED TO STOP SUDDENLY. BRAKES LOCKED AND THE CAR WENT INTO A TERRIBLE SKID. WAS UNABLE TO CONTROL THE BRAKES BY PUMPING. THE CAR EVENTUALLY SKIDDED OFF THE ROAD INTO A DITCH CAUSING TREMENDOUS FRONT-END DAMAGE. AIR BAGS NEVER DEPLOYED. CAR WAS GOING ABOUT 25 MILES/HOUR WHEN BRAKES WERE APPLIED.

Jan 15, 2004

Crash: 1

SUSPENSION,TIRES

1 complaint

I HAD TO REPLACE TIRES ON THIS VEHICLE AT 29,000 MILES TO DUE EXCESSIVE WEAR ON THE TIRES. THESE TIRES HAD BEEN ROTATED AND BALANCED EVERY 4,000 MILES. I ASSUMED THE TIRES HAD TO BE REPLACED BECAUSE THE TIRES WERE MANUFACTURED POORLY.*AK WELL AFTER REPLACING THE ORIGINAL TIRES WITH GOODYEAR TIRES, I HAVE AGAIN HAD PROBLEMS WITH TIRE WEAR ON THE FRONT PASSENGER SIDE TIRE. I HAD A GOODYEAR SERVICE TECHNICIAN INVESTIGATE THE ISSUE AND WHEN THE TIRE WAS REMOVED THE INNER TIE ROD ASSEMBLY WAS VERY LOOSE. THE INNER TIE ROD HAD TO BE REPLACED. THIS IS A SERIOUS ISSUE. THIS CAN CAUSE INSTABILITY IN VEHICLE CONTROL RESULTING IN AN ACCIDENT. THE CHEVROLET DEALERSHIP WHERE I PURCHASED THE VEHICLE SAID THAT THEY HAD NEVER SEEN A PROBLEM. THE EXTENDED WARRANTY THAT I PURCHASED SPECIFICALLY DOES NOT COVER THIS ITEM. I OBTAINED A SERVICE BULLETIN THAT INDICATES THESE PARTS HAVE TO BE REPLACED QUITE FREQUENTLY. I AM VERY DISAPPOINTED IN THE SERVICE FROM CHEVROLET AND THE ANSWERS GIVEN TO ME BY THE LOCAL DEALERSHIP. I SAW THE INNER TIE ROD CONNECTION WITH MY OWN EYES AND IMMEDIATELY COULD TELL THERE WAS AN ISSUE. VERY CURIOUS THAT THERE HAVE BEEN SO MANY ISSUES WITH TIRES AND STERRING ON THESE VEHICLES AND NOW I SEE THIS PROBLEM WITH THE TIE ROD. I BELIEVE THIS SHOULD WARRANT SOME INVESTIGATION.

Dec 08, 2003

FUEL SYSTEM, GASOLINE,EQUIPMENT

1 complaint

2002 CHEVROLET SUBURBAN VIN# [XXX] DEALER REPORTED COOLANT LINE FAILURE CAUSED BY FRICTION OF METAL COOLANT LINE RUBBING AGAINST FUEL TANK. DEALER REFUSED TO REPAIR AND REMOVE/REPAIR CAUSE OF LINE COMING INTO CONTACT WITH FUEL TANK. *LA INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Oct 11, 2003

STEERING,SUSPENSION,ENGINE AND ENGINE COOLING,POWER TRAIN,STRUCTURE,SEATS

1 complaint

OIL CONSUMPTION, STEERING COLUMN, SIDE DOOR PANELS, REAR-END, SEATS CRACKING, FRONT POPPING NOISE, STEERS TO RIGHT CONSTANTLY. THIS HAS BEEN AN ONGOING THING SINCE WE BOUGHT THE VEHICLE NEW IN 2001. WE HAVE COMPLAINED TO THE CONSUMER REPORTING AGENCY HERE IN N.C. AND ALSO TALKED TO THE DEALER AND MANUFACTURE ON NUMEROUS OCCASIONS. DEALER SAID THEY HAVE HAD SEVERAL VEHICLES WITH OIL CONSUMPTION THAT THEY HAVE TRADED BECAUSE OF IT AND THEY JUST KEPT TELLING US IT IS WITHIN MANUFACTURE LIMITS. THEY HAVE TRIED TO FIX THE OIL PROBLEM BUT WITH NO SUCCESS. ALSO THE STEERING HAS BEEN BROKEN DOWN TWICE BECAUSE OF ITS PROBLEM. THE DOOR PANELS ARE STILL NOT FIXED AFTER 2 TRIES. THE REAR-END HAS BEEN WORKED ON 2 TIMES BECAUSE OF DIFFERENTIAL FLUID, THE STEERING WHEEL STILL SCRUBS WHEN TURNING TO THE RIGHT AND THE DRIVER'S SEAT IS STARTING TO CRACK. THE CONSUMER PEOPLE IN RALEIGH WILL NOT HELP US AFTER WE FILLED THE COMPLAINT, THEY WROTE US AND TOLD US TO HIRE A LAWYER AND THE MANUFACTURE ONLY OFFERED US A $1000.00 OWNER/LOYALTY CERTIFICATE TOWARDS A NEW VEHICLE. WHAT IS OUR NEXT STEP WITHOUT HIRING AN ATTORNEY? *JB

Oct 06, 2003

SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING,VISIBILITY

1 complaint

THERE WAS AN ENGINE KNOCKING PROBLEM. THE DEALER AND THE MANUFACTURER WERE CONTACTED. THE CONSUMER WAS GIVEN A LETTER THAT CERTIFIED THAT THE MANUFACTURER WAS AWARE OF THIS PROBLEM, AND THE VEHICLE WAS OKAY TO DRIVE. THE CONSUMER DISAGREED, AND FELT THE VEHICLE WAS NOT SAFE. *AK THERE WAS A NOISE, RUBBING SOUND WHEN THE BRAKES WERE APPLIED. THERE WERE KNOCKS DURING THE INITIAL START OF THE DAY, AND THE WINDOW WAS NOISY WHILE OPERATING AS THE REGULATOR CABLE WAS LOOSE. *SCC *JB

Aug 15, 2003

STEERING,SERVICE BRAKES, HYDRAULIC,EQUIPMENT

1 complaint

I AM WRITING TO COMPLAIN ABOUT THE SECOND FAILURE OF THE "POWER ASSIST" FEATURE ON MY 2001 CHEVROLET SUBURBAN. THE FIRST FAILURE OCCURED DURING JANUARY OF 2002, AND THE POWER STEERING PUMP WAS REPLACED AT FOX CHEVROLET DEALERSHIP IN LAUREL, MD. IN THE 2002 EVENT, I EXPERIENCED A HIGH PITCH WHINING AND VIBRATIONS IN THE STEERING, AS WELL AS THE BRAKE PEDAL. IN EFFECTING THIS REPAIR, CHEVROLET REPLACED THE POWER STEERING PUMP. DURING THE LATTER PART OF NOVEMBER 2002, THE HIGH PITCH WHINING AND VIBRATION RETURNED. I TOOK THE VEHICLE TO BILL SEIDLE'S CHEVROLET IN CLERMONT, FL IN NOVEMBER OF 2002, AND WAS TOLD THAT THERE WAS NOTHING WRONG WITH THE STEERING OR BRAKING SYSTEM. UNFORTUNATELY, THEY WERE WRONG. ON TUESDAY EVENING, 2/4/2003, WHILE DRIVING WITH MY SEVEN YEAR OLD, THE SAME HIGH PITCH WHINING, AND PULSING IN THE BRAKE PEDAL RETURNED. THIS TIME IT RESULTED IN THE TOTAL LOSS OF POWER STEERING AND BRAKES WHILE EXITING A LOCAL HIGHWAY SYSTEM IN THE ORLANDO AREA. FORTUNATELY, I WAS DRIVING AS IT TOOK QUITE A BIT OF STRENGTH, TO STEER AND STOP THE VEHICLE AFTER THE LOSS OF THE POWER ASSIST SYSTEM. AT WHAT POINT DOES THE FAILURE OF SUCH A CRITICAL PART OF THIS VEHICLE GET LABELED AS A DEFECT IN THIS SYSTEM. THE FAILURE OF THIS SYSTEM, COULD HAVE CAUSED INJURY TO ME AND MY FAMILY (SON). HAD MY WIFE BEEN DRIVING THIS TRUCK, THE RESULT MAY HAVE BEEN GRAVELY DIFFERENT. I PURCHASED THIS VEHICLE BECAUSE OF THE REPUTATION FOR DURABILITY IN THE INDUSTRY, WITH THE EXPECTATION OF PURCHASING A QUALITY VEHICLE. I AM NOW FEARFUL OF PUTTING MY FAMILY IN THIS VEHICLE AFTER A SECOND FAILURE OF THIS CRITICAL SYSTEM. I AM REQUESTING THAT I BE CONTACTED AS SOON AS POSSIBLE BY SOMEONE THAT CAN ADDRESS MY CONCERNS. I AM CONCERNED ABOUT PLACING MY FAMILY IN A VEHICLE THAT HAS HAD THE POWER STEERING/BRAKING SYSTEM FAIL TWICE.

Feb 13, 2003

SUSPENSION,PARKING BRAKE,ENGINE AND ENGINE COOLING,FUEL SYSTEM, OTHER,ELECTRICAL SYSTEM,SEATS

1 complaint

WE BOUGHT A 2001 CHEVY SUBURBAN , BRAND NEW. SINCE WE OWNED IT, THE AIR CONDITIONER MOTOR FAILED THE FIRST MONTH, FRONT LEFT SHOCK POPS WHEN TURNING, DRIVER'S SEAT WARMER DOESN'T WORK (POSSIBLE FAULTY SWITCH), THE 5.3 LITER ENGINE KNOCKS AND PINGS LIKE CRAZY EVEN WHEN USING 93 OCTANE FUEL ON A STEADY BASIS. THE FRONT PASSENGER SEAT WAS FOUND TO HAVE CRACKED SEAT RAILS BUT DEALER HAD NO REPLACEMENT RAILS, HAVE TO ORDER THEM. GAS GAUGE DOESN'T READ RIGHT (WHEN ON THE RED LINE IT STILL HAS 6 GALLONS IN THE TANK OR 20% FUEL LEFT) THE THING IS A PIECE OF CRAP! GM DIDN'T GIVE A DARN EITHER. IF YOU CALL TO COMPLAIN YOU GET THE RUN AROUND. THIS IS THEIR TOP OF THE LINE PASSENGER TRUCK (SUBURBAN LT) AND DEFINITELY NOT SOMETHING THEY SHOULD BE PROUD OF. I DEFINITELY WILL NOT BUY ANOTHER, MY PARENTS JUST BOUGHT A NEW FORD EXPEDITION SINCE THEY SAW ALL THE CRAP BREAKING ON THIS THING. OTHER FRIENDS HAVE ALSO NOT GM AFTER SEEING FIRST HAND MY BRAND NEW LEMON. ANOTHER FRIEND OF MINE IS ON HIS 3RD REPLACEMENT MOTOR FOR HIS CAMARO WINDOW. HE BOUGHT AC DELCO MOTORS EACH TIME AND THEY ALL STOPPED WORKING WITHIN ONE YEAR. ALL OF THESE PRODUCTS, INCLUDING MY SUBURBAN ARE BEING MADE IN MEXICO I JUST FOUND OUT. I THINK THAT THEY MUST HAVE A BIG PROBLEM WITH QUALITY CONTROL DOWN THERE OR THEIR SAMPLING SIZE IS NIL. WELL I HOPE GM HAS MADE A BUNDLE OF PROFITS OFF NAFTA BECAUSE THEY'VE DEFINITELY LOST AT LEAST 7 SALES THAT I KNOW OF DUE TO MY $40,000 PIECE OF CRAP. I WOULDN'T RECOMMEND THIS CAR TO ANYONE. I HAVE HEARD OF OTHERS COMPLAINING OF THE SAME PINGS/KNOCKS IN THEIR 5.3 LITER GM ENGINES. DOES ANYONE KNOW OF A CLASS ACTION LAWSUIT REGARDING THIS? OH AND THE EMERGENCY BRAKE IS WAY TOO LOOSE.

Jan 12, 2003

STEERING,POWER TRAIN,EXTERIOR LIGHTING,STRUCTURE,VEHICLE SPEED CONTROL

1 complaint

AUTOMATIC TRANSMISSION FAILED, DEALER ONLY "RECONDITIONED" THE TRANSMISSION, I HAVE TAKEN THE VEHICLE BACK TO THE DEALER FOR TRANSMISSION REPAIRS;RUBBING , BUMPING NOISES FROM TRANSMISSION, I HAVA NOT TRUST IN THIS VEHICLE BECAUSE OF THE LONG HISTORY OF MECHANICAL PROBLEMS AND DEFECTS, I WANT THE MANUFACTURER TO REPLACE THIS VEHICLE AND NOT WAIT UNTIL A MECHANICAL FAILURE HURT ME OR MY FAMILY OR INNOCENT PEOPLE IN THE ROAD. PLEASE HELP ME . NLM

Sep 14, 2002

STEERING,SUSPENSION

1 complaint

REAR END WENT OUT ON THREE OCCASIONS. DEALER HAS REBUILT REAR END ONCE AND REPLACED RING AND PINION WEARING AND SEAL. PLEASE PROVIDE FURTHER INFORMATION.*AK

Apr 24, 2002

POWER TRAIN,VISIBILITY

1 complaint

THE VEHICLE IS IN AWD OR 4-WHEEL DRIVE - STEP ON THE GAS AFTER BEING STOPPED, THE TRANSMISSION SOUNDS AS IF IT IS ABOUT TO FALL OFF. WHEN IN 4-WHEEL DRIVE THE VEHICLE IS DIFFICULT TO TURN. ALSO, REAR HEATER TAKES 30 MINUTES TO HEAT UP, AND THEN ONLY BLOWS LUKE WARM AIR WHEN THE GAS PEDAL IS DEPRESSED. MANUFACURER STATES BY DESIGN.*AK

Feb 19, 2002

SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING,VISIBILITY,UNKNOWN OR OTHER

1 complaint

VEHICLE HAS SHUT OFF SEVERAL TIMES WHILE TRAVELING AT HIGHWAY SPEED. AFTER COASTING TO THE SHOULDER AND SEVERAL ATTEMPTS, THE TRUCK RESTARTS. THE TRUCK ALSO SPUTTERS DURING ACCELERATION. THE DEALER HAS REPLACED THE CRANKSHAFT SENSOR SEVERAL TIMES AND HAS REPLACED FOUR WARPED ROTORS THAT CAUSED THE BRAKES TO BE SPONGY. TWO OF THE POWER WINDOW MOTORS HAVE BEEN REPLACED DUE TO INOPERATIVE WINDOWS. THE OIL LEVEL IN THE TRUCK DROPS BETWEEN (FREQUENT) VISITS TO THE DEALERSHIP. THE LOW OIL INDICATOR LIGHT FIRST ILLUMINATED WHEN THE TRUCK HAD ONLY BEEN DRIVEN 3900 MILES. THE DEALERSHIP CAN'T FIND A LEAK.*AK

Oct 10, 2001

2001 CHEVROLET Suburban Problems & Complaints

VIN Decoder

Complaints by Component

Where to Find VIN for Problems Check

Understanding VIN Structure for Problem Reports

How to Check 2001 CHEVROLET Suburban Problems in 3 Steps

Locate Your VIN

Review by Component

Check Safety Issues

Frequently Asked Questions

How many problems does the 2001 CHEVROLET Suburban have?

What are the most common problems with 2001 CHEVROLET Suburban?

Where does this 2001 CHEVROLET Suburban problem data come from?

How do I report problems with my 2001 CHEVROLET Suburban?

Where can I find my VIN to check problems?

Is the 2001 CHEVROLET Suburban reliable?

Other Years - CHEVROLET Suburban Problems

Other CHEVROLET Models

Similar Brands