2024 CHEVROLET Suburban Problems

Complaints Reported

Complaints by Component

ENGINE

7 complaints

I took my 2024 Chevrolet Suburban to get repairs associated with GM safety recall N252494000 - L87 Engine Loss of Propulsion. My vehicle "passed" the test, so the "correction" employed by GM is that "vehicles that pass inspection will be provided a higher viscosity oil, which will also require a new oil fill cap, an oil filer replacement, and an owner's manual insert." All of this was done free of charge. However, the owner's manual insert states that "For future engine oil changes, use SAE OW 40" oil. This updated owner's manual insert, which is provided as a solution to GM's recall of a faulty connecting road and/or crankshaft, causes the future costs of oil changes to increase from $160.00 to $230.00. Assuming quarterly oil changes, this will increase the cost of operating this vehicle to increase by $2,800 over an estimated 10 year lifespan. This increase should be covered by GM. GM sent me a letter that states, "If your dealer fails or is unable to remedy this defect without charge, or within a reasonable amount of time, you may submit a written complaint to the Administrator, NHTSA." By passing on the cost of the increase in oil change for all future oil changes, GM failed to remedy this defect without charge. I submit this claim because GM filed to remedy this defect without charge. Please see highlighted portions of attached documents in support.

Oct 25, 2025

I parked at my home, approximately 5 minutes after arriving home my grandson ran in yelling papa your car is on fire. The engine was on fire, shooting flames onto the windsheild. The cause of fire is unknown at this time.

Apr 18, 2025

Fire: 1

I was entering the interstate, at 65 miles per hour, and went to set the cruise once I reached 70mph, and noticed that I was losing power, the engine had stopped and we dangerously lost speed on a interstate where folks were traveling north of 75-80 mph. I costed to the shoulder and tried to reset with no luck. We called Onstar and had it towed to Hendrick or Monroe NC. We found out that this was an engine failure and the long block had to be replaced. This left us stranded without a car to drive to our cruise —GM told me I could buy plane tickets and they’ve never denied reimbursement. Unfortunately they denied it once I submitted all the receipts. It been a horrible experience with no help from GM.

Mar 29, 2025

We were driving down the [XXX] in Wichita KS when our 2024 Suburbans engine shut off and the car went into neutral. The display said “ "conditions not correct for shift". We were able to safely coast to the nearest exit [XXX] and we completely stopped at the bottom of the exit ramp. We contacted onstar who dispatched Kansas Highway Patrol who blocked off the exit until we could get the vehicle towed. The car is currently at the dealership, being that it is Sunday they are closed so more information tomorrow on the issue. The photos are of the car being towed from The incident location and dropped off at the dealership. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Mar 23, 2025

6.2L engine failure at 9600 miles

Jan 22, 2025

+ 2 more complaints for this component

ENGINE AND ENGINE COOLING

5 complaints

The contact owns a 2024 Chevrolet Suburban. The contact was notified of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact requested a work order on the vehicle for the recall repair and the dealer refused. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was also made aware of the issue and refused to create a work order for the recall repair. The contact was provided a case number. The vehicle was not repaired. The contact had not experienced a failure.

Sep 22, 2025

The contact's son owns a 2024 Chevrolet Suburban. The contact stated that his son had received notification of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). The contact's son had been calling the local dealer and was informed that parts were not yet available for the recall repair. The contact was informed by his son stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not informed of the issue. The contact had not experienced a failure.

Sep 05, 2025

See attached document for complaint.

Jul 10, 2025

The contact owns a 2024 Chevrolet Suburban. The contact received notification of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

Jun 23, 2025

The contact owns a 2024 Chevrolet Suburban. The contact received notification of NHTSA Campaign Number: 25V274000(Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed and depressing the accelerator pedal, the vehicle intermittently failed to accelerate as intended before slamming into gear. The local dealer was contacted. No further information was available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 4,000. VIN tool confirms parts not available.

Jun 12, 2025

SERVICE BRAKES,ENGINE

1 complaint

The contact owns a 2024 Chevrolet Suburban. The contact stated that while depressing the accelerator pedal, there was a loud rattling sound coming from the engine. The contact stated that while depressing the brake pedal, the vehicle failed to respond as intended while driving with her grandchildren inside the vehicle. The brake failure warning light was illuminated. The contact stated that the vehicle lost power and coasted and slowed down, and the contact shifted into park(P). The contact stated that the failure had occurred on two separate occasions. A dealer was contacted. The vehicle was taken to a dealer, where it was diagnosed; however, the diagnostic result was unknown. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 16,600.

Oct 24, 2025

SERVICE BRAKES,ENGINE,FORWARD COLLISION AVOIDANCE

1 complaint

i pulled on to the road and i heard a loud knocking and my vehicle started skipping and wouldn't go. the lights on the dash lit up and said, "brake failure" and "emergency brake failure" and i had no brakes. I managed to coast into a parking lot. The engine light was on. I turned the vehicle off and waited about 5 minutes and turned it back on, The engine light remained. The first time this happened I was going down the road and the vehicle started sputtering, the emergency brake light came on the dash and the car shut off. It has a rough idle when you start it. I am terrified of this car. I have grandbabies in the car with me, Had i been on the highway either time i would have caused a terrible accident. The dealer says they can't get the car to do it so they can't fix anything. It has happened twice so you know it will again.

Oct 24, 2025

POWER TRAIN

1 complaint

The vehicle only has ~39,000 miles on it and the transmission went out and the car is not drivable. The dealership said it is a faulty valve body and that the part is on national back order and could take 2 to 6 months or even longer to get the part before they can start work.

Aug 29, 2025

ELECTRICAL SYSTEM,ENGINE

1 complaint

The engine light comes on and then the rpm's drop to 35 and a notification comes up that says "reduced acceleration. driving with caution". If I stop and turn of the vehicle and restart the rpm's will be better but the truck still seems to have a difficult time increasing in rpm's and accelerating gears. It's incredibly dangerous as if I'm driving at a substantial speed on the highway or freeway and it drops rmp's rapidly I'm likely to be in an accident which could be detrimental. The dealer has had my vehicle on two separate occassions. The most recent time they've had it for 5 days and still do not know what's wrong with it. The engine light will not turn off.

Aug 18, 2025

AIR BAGS,STRUCTURE,ENGINE

1 complaint

Since purchasing the vehicle on September 27, 2024, I have experienced a series of troubling issues that raise serious concerns about its design, manufacturing, and overall safety, including: Airbag system malfunction: My airbags were nonfunctional for over a month. Tire-related issues: Required full replacement of the initial set of tires. Persistent alignment problems Bluetooth audio problems: Poor quality and connectivity with multiple phones, resolved only after a service visit in May 2025. Defective seat frame: Rear passenger-side bucket seat required full replacement. Defective paint: Blisters and bubbles in the rear quarter panel paint. Fuel module failure: Most concerning, the vehicle abruptly stopped on the road last week and required towing. I was later told the cause was a fuel module failure. Each of these issues is concerning on its own. Taken together, they represent a troubling pattern of unreliability and potential risk to my safety and that of others on the road. They’ve also resulted in a significant loss of my time. This vehicle has spent over a month at the dealership for service—astounding for a truck that’s only eight months old. These are the kinds of delays and disruptions I specifically try to avoid by purchasing and maintaining new Chevrolet vehicles.

Jun 11, 2025

ELECTRICAL SYSTEM,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

1 complaint

I have had my cruise control set and my car will slam on the brakes with no vehicles in front of my car or on each side. This has happened multiple times, it doesn’t matter if I am going 40MPH or 60+MPH. I have taken it in and they say there is nothing they can do for the issue. I’m worried for the safety of myself, my family, and my unborn child. As well as any cars around (behind me potentially) when this happens. I do not want to unintentionally cause an accident.

Jun 09, 2025

EXTERIOR LIGHTING

1 complaint

The contact owns a 2024 Chevrolet Suburban. The contact stated that upon brushing snow off the vehicle, the contact noticed that there was snow inside the headlights, which later turned into ice and dimmed the headlights. The contact stated that while driving at an undisclosed speed, the failure recurred, causing the contact to pull over to the side of the road to clean the headlights. The dealer was not notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 360.

Mar 18, 2025

ELECTRICAL SYSTEM,SERVICE BRAKES,BACK OVER PREVENTION

1 complaint

The check engine light came on at 14k miles indicating there was an emissions error. The brakes squeal and have had to be replaced 3 times since the original purchase in March of 2024. After the third replacement of brakes they still squeal. Even if the car is not braking it makes the noise. The radio shuts on and off constantly. Chevy reported they are aware of the issue but there is no fix at this time. The dealerships reset the radio but the issue persists. I’ve had to park the car because I’m afraid the brake issue is much more than they’re willing to admit.

Feb 28, 2025

CHILD SEAT

1 complaint

The contact owns a Nuna Rava Car Seat, Model Type: Convertible, Model Number: CS05013-GRN, Manufactured Date: July 16, 2016. The contact stated that the harness buckle became difficult to adjust while attempting to secure the child in the car seat. The contact received notifications of NHTSA Campaign Numbers: 24C002000 (Child Seat); however, the parts to do the recall repair were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue.

Jan 31, 2025

POWER TRAIN,ENGINE

1 complaint

On[XXX], at approximately [XXX], while driving on [XXX] at a speed of 80 mph, my vehicle suddenly lost all power and shut down without warning. I had no choice but to steer to the shoulder lane amidst high-speed traffic on the busy interstate. After coming to a stop, the car would not restart, leaving me stranded in a highly precarious situation. As the weather conditions worsened, turning into a blizzard, and darkness set in, I contacted GM Roadside Assistance for help. I was informed that assistance would take at least an hour to arrive. Feeling unsafe, I called local law enforcement. The officers arrived and parked behind my vehicle with their flashers on to ensure approaching drivers would slow down and avoid an accident. This was an extremely distressing and frightening experience. After an hour, GM Roadside Assistance called back and informed me they were unable to find an operator to tow the vehicle. By this time, the officers on-site had contacted a local tow company for my safety. The tow company advised me that I would need to pay in cash for their services, which I accepted due to the urgency of the situation. They towed the vehicle from [XXX] to their yard in Douglas, Wyoming. I then arranged for a ride to Cheyenne, Wyoming, where I had to report to work that night. This incident not only jeopardized my safety but also left me with significant unexpected expenses and inconvenience, all due to what I believe is a manufacturing defect in the vehicle. A new vehicle should not experience such catastrophic failure, and the delayed response from GM Roadside Assistance compounded the problem. I respectfully request the following actions 1. A thorough investigation into the root cause of the sudden failure. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Jan 24, 2025

⭐

4.6/5.0

49 reviews

Frequently Asked Questions

How many problems does the 2024 CHEVROLET Suburban have?

The 2024 CHEVROLET Suburban currently has 22 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2024 CHEVROLET Suburban?

The most common problems reported for the 2024 CHEVROLET Suburban are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2024 CHEVROLET Suburban problem data come from?

All problem and complaint data for the 2024 CHEVROLET Suburban comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.