How many problems does the 2024 FORD Bronco Sport have?

The 2024 FORD Bronco Sport currently has 55 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2024 FORD Bronco Sport?

The most common problems reported for the 2024 FORD Bronco Sport are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2024 FORD Bronco Sport problem data come from?

All problem and complaint data for the 2024 FORD Bronco Sport comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.

2024 FORD Bronco Sport Problems

ELECTRICAL SYSTEM

8 complaints

The contact owns a 2024 Ford Bronco Sport. The contact stated that while driving at an undisclosed speed, the vehicle vibrated, and the contact stated that there was an abnormal white noise coming from the rear of the vehicle. No warning lights were illuminated. The contact stated that on another occasion, while driving 60 MPH, there was smoke coming from under the hood. The contact pulled over to the side of the road and shifted in park(P). The contact opened the hood and noticed that the engine had overheated. No warning lights were illuminated. The contact waited for the engine temperature to lower. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired. The contact stated that the failure persisted. On another occasion, while driving 65 MPH in the rain, the steering wheel pulled to the right. The contact was able to control the steering wheel and continued to drive at a slower speed. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired. Most recently, the contact stated that there was an abnormal static sound coming from the electronics inside the vehicle. The contact stated that the abnormal sound was also heard with the engine turned off. The contact stated that the magnetic vibrations and potential unauthorized electronic interference affected her health. The contact used the PHYPHOX App to get the magnetic and electronic interference readings. The contact stated that while the vehicle was being diagnosed, a rental was provided. The rental was a 2024 Ford Bronco Sport, and the contact experienced the same failure. The manufacturer was made aware of the failure. The failure mileage was approximately 1,000.

Aug 18, 2025

The contact owns a 2024 Ford Bronco Sport. The contact stated that the engine knock sensor and the oil pressure sensor failure warning lights were illuminated; however, the vehicle had not displayed any failures. The vehicle was taken to the dealer who diagnosed the vehicle and determined that the wires underneath the vehicle were defective due to bite marks. The contact stated that after the wires were repaired, the contact attempted to start the vehicle, but the vehicle failed to start. The vehicle was towed back to the dealer who determined that there were bite marks on the wires again. The contact was informed that the insulation on the wires were soy-based, and squirrels were chewing on the insulation. The wires were replaced again. The manufacturer was not informed of the failure. The failure mileage was approximately 6,031.

May 07, 2025

The contact owns a 2024 Ford Bronco Sport. The contact stated that while attempting to start the vehicle, the vehicle failed to start. The vehicle was towed to the dealer, and it was determined that there were bite marks on the electrical wires under the vehicle. The contact was informed that the insulation of the wires underneath the vehicle were soy-based and was being chewed on by squirrels. The wires were replaced. The manufacturer was not informed of the failure. The failure mileage was unknown.

May 07, 2025

Vechicle is again in Battery saver Mode. Vechicle not safe to drive.

Jan 25, 2025

Vechicle battery will not hold a charge, longer than a few days. Ford can see the BCM Faults on there end.

Jan 24, 2025

+ 3 more complaints for this component

POWER TRAIN

7 complaints

The transmission failed to go in gear. The transmission was replaced and fixed by the dealership.

Nov 22, 2025

I believe the transmission has an issue. The car was started and it quickly went into reverse and sped up trapping my wife between the door and a tree as she was exiting the vehicle to swap seats for me to drive. No known warnings were issued by the vehicle prior to the incident on 6/7/2025. The previous recall for the BCM & PCM was completed on 2/27/2025 by our local Ford dealer

Jun 07, 2025

Crash: 1

Injuries: 1

The contact owns a 2024 Ford Bronco. The contact stated while driving at an undisclosed speed, the contact noticed a burning odor in the interior of the vehicle. The contact stated an error message indicated service 4WD was displayed. In addition, the contact stated that when the vehicle was parked in the garage, the contact noticed a burning odor on the exterior of the vehicle. The vehicle was taken to the dealer, however the failure was not duplicated. The dealer performed an oil change. The contact stated that seven days later, the failure occurred. The contact stated while driving at an undisclosed speed, the contact noticed fire coming from underneath the hood. The contact and her daughter were occupants of the vehicle. The contact stopped and parked the vehicle. The contact and her daughter exited the vehicle. No injuries were sustained. The vehicle was towed to the dealer, which was the dealer that performed the diagnostic test and the oil change the week prior to the failure. The contact received documentation which provided several unknown parts related to the power train and electrical wiring that were replaced. The contact stated that no official failure diagnostics were provided. The vehicle manufacturer was not made aware of the failure. The failure mileage was approximately 18,000.

Jun 05, 2025

Fire: 1

The contact owns a 2024 Ford Bronco Sport. The contact stated that while driving 75 MPH, the vehicle started to lose power. The WRENCH symbol warning light was illuminated with a message of a failure with the power train displayed. The vehicle was taken to a dealer however, the dealer was unable to determine the cause of the failure. The dealer replaced the knock sensors, and a software update was performed. The vehicle was repaired; however, the failure persisted while driving for long distances. On another occasion, while driving from State to State, the wrench symbol warning light illuminated with the power train failure message displayed. The contact also received a notification on his cellphone. The vehicle was repaired by another dealer; however, the contact and the dealer expected that the failure could recur. The manufacturer was made aware of the failure. The failure mileage was approximately 4,000.

Apr 16, 2025

I Was in Reverse backing out and stopped with the brake and rolled the gear dial to drive until foot off brake and it stayed stuck in reverse and I moved backwards and hit a car behind me. I braked again and looked to make sure I was in drive, And I was. Then, i took my foot off thee brake and it moved forward. Also I notice a big delay in drive after having brake applied. I think the gears are sticking. Or even a 2-4 second delay to switch from gear to gear.

Apr 03, 2025

Crash: 1

+ 2 more complaints for this component

UNKNOWN OR OTHER

5 complaints

extreme loud vibrating noise coming from sunroof while driving at or above 35 mph. it may be bad design for rubber seal and body trim for the sunroof. for example: automatic car washing - hard rolling brushes hitting the top of the vehicle during the wash process, then there is the high pressure water rinsing from different directions, followed by a high wind vortex that causes every exterior surface extreme pressure and force. so, a few trips to the car wash, now causes your sunroof seal failure which may lead to a sunroof blow out while driving at 60mph on the high way... please ALERT ALL to this danger. sunroof seal failure. sunroof blowout. sunroof vibrating.

Oct 30, 2025

I have cut my arm two times on the door lock while exiting the vehicle. The door lock sticks out and the point is very sharp. I have blood thinner issues and it could cause severe problems. It occurs when the door cannot be opened all the way and you turn to exit. This needs to be rounded off and the flashing from casting the part needs to be sanded off

Jul 21, 2025

The Heritage edition of the Bronco Sport has a piece white trim on the dashboard that causes a very distracting reflection on the windshield directly in the driver's line of sight. I feel there should be a recall for this piece of trim — replacing it with the regular dark strip used on the other Bronco Sport editions. Thank you for your consideration!

May 27, 2025

While driving on the freeway, my Ford's sunroof spontaneously shattered. There were no vehicles in front of me, I live in San Diego County and the weather was in the mid-60's and I did not have my air on. It sounded like an explosion or gunshot. I immediately pulled off on to the shoulder and saw the shattered sunroof, and since I was about to exit to my house, I continued home and called the California Highway Patrol to report a potential gunshot to my vehicle. However, when the office arrived, he believed it was an implosion from the inside of the vehicle outward. This did appear to be the correct assessment as there was no glass inside the vehicle (I had seen glass fragments falling around the outside of my vehicle and in front of my windshield at the time of the explosive sound). Also, the glass was bent out towards the top of the vehicle consistent with an inside to outside breakage. I took it to my local Ford dealership and Ford has accepted responsibility for the defect and will replace my damaged sunroof at their cost.

Apr 16, 2025

When I start my Bronco, daily, there a vibration even as I drive out of my garage. Once I’m on the road I don’t feel the vibration. I have taken my Bronco to the dealer 2-3 times and they tell me the Bronco doesn’t do as I stated to them. I can’t make this up, I think the mechanics are not sure what is wrong. I love my Bronco and have owned many fords over the years and have never had this issue. They did tell me, I should drive it more and the vibration should stop. At least they admitted it was happening. I drive 16 miles a day, so I’m not sure how much I should drive daily , I’ve never been told I should drive more

Oct 24, 2024

TIRES

3 complaints

See attached document for complaint.

Sep 05, 2025

The contact owns a 2024 Ford Bronco Sport equipped with Continental Tires, Tire Line: Cross Contact, Tire Size: 225/65R/17, and DOT Number: [XXX] . The contact stated that while driving at approximately 70 MPH, the contact heard an abnormally loud sound coming from the rear end of the vehicle, and the contact noticed that the rear passenger's side tire had sustained a blowout. Upon inspection, it was discovered that the tread of the tire had separated. The dealer was contacted. The vehicle was not diagnosed or repaired. The tire was original equipment. The tire was not replaced. The manufacturer was notified of the failure. The vehicle failure mileage was 8,000. The tire failure mileage was 8,000. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Aug 01, 2025

All 4 Continental PRO CONTACT TX tires on 1 week old brand new purchased Ford Bronco Sport VIN [XXX] from Ford Dealer Swelling on Sidewalls in various points. After researching amongst other Bronco Sport Forums issue appears to be common failure on New Bronco Sports equipped with Continental PRO CONTACT TX tires. Requested tires to be changed at Dealer, they found 1 Bronco Sport with Balled up Sidewall issues and wanted to replace "like for like" admitting they have a some sort of FACTORY defect but would not exchange tires for ones with "OUT" Factory Defect. I believe there is Faulty Construction on Sidewall of tire or Like FORD Dealer stated some sort of MANUFACTURER DEFECT. On certain CONTINENTAL PRO CONTACT TX tires from Factory. Symptoms were first noticed 6 days after having possession of new vehicle. And the Swelling appears to be moving TOWARDS the tire TREAD itself. The swelling has become increasingly noticeable and raises concerns about the safety and performance of these tires for my Family Vehicle and others having the same issues. Given the importance of tire integrity for vehicle safety, I believe this issue warrants immediate attention and investigation. I would appreciate it if you could investigate this matter and advise on any necessary actions or precautions that should be taken. Ensuring the safety of consumers is crucial, and I trust that NHTSA will address this issue promptly. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Aug 24, 2024

STRUCTURE

3 complaints

The rear quarter panel glass on the vehicle's passenger side cracked. This is consistent with Recall Reference Number: 24S10 in which the adhesion of the glass is known to fail.

Jul 18, 2025

See attached document for complaint.

Feb 21, 2025

Moof roof popped up from the center ripping at all edges, causing loud boom sound. Glass shattered. No drastic change in temperature. No impact of object. Newly purchased. Dropped off at dealership to investigate.

Dec 19, 2024

FUEL/PROPULSION SYSTEM

2 complaints

poor engine performance, including rough idling, misfires, engine stalls, sometimes difficult to start or no-start situation.

Sep 10, 2025

I’d like to open a customer concern case. While I was driving on the freeway on, my gas tank was punctured after hitting debris in the road. It was a standard highway situation—not off-roading or anything extreme. The fact that the gas tank was damaged to the point of leaking or requiring repair is very concerning. It was a very large rupture. I believe the underbody protection may not be adequate, and I’m worried this could be a design or safety issue. I’ve taken photos and have a repair estimate. It was a very dangerous situation as one spark from heat could have sent my brand new Bronco sport into flames. This all happened on the 5 freeway on the grapevine in California. I consider myself very lucky

Mar 26, 2025

ENGINE,FUEL/PROPULSION SYSTEM

2 complaints

I reached out to ford due to my 2024 bronco sport overheating and running hot. During the time of that complaint I was advised that my bronco currently has a recall that the fuel tank needs to be replaced but it is currently being deemed as non safety and will only be addressed if the vehicle is in for service. I was also advised that due to this recall it is currently a part of fords customer satisfaction program. Anything fuel related should be deemed as a safety recall considering fuel is a flammable chemical. I have requested a buy back as I no longer feel safe operating the vehicle or comfortable transporting my daughter in the vehicle as it aligns too closely with the known fuel safety recall currently present on some 2021-2024 bronco sports.

Sep 10, 2025

There is a recall for the fuel injectors that is a serious issue and can cause the engine to catch fire but there is no fix and I am afraid to drive my car.

Jul 31, 2025

ENGINE

2 complaints

Recall 25V467 can result in vehicle fire and manufacturer does not have a remedy. This is a lease and I would like to return the vehicle back because it is a safety hazard.

Sep 08, 2025

Auto start / stop feature stopped working after recall 24S24. Took to dealership where battery was diagnosed at 57%. Had no indication battery was failing. Recall reprogram did not resolve issue.

Mar 11, 2025

POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE

2 complaints

The Powertrain of this Ford Bronco Sport (2024) with only 12,000 miles on it malfunctioned while the driver was on a major highway. No control over gears, engine power, etc. Had to pull over in heavy traffic. Fortunately there was a shoulder, or this would have been a major safety risk for the driver and other vehicles and would likely have resulted in an accident. Apparently, this malfunction is related to battery issues as well and can affect the emergency caution flashers. The vehicle was inspected by Ford after being towed to a local dealership and was told that this was part of a recall on other Ford Broncos. A few days later, was told that Ford dealership was replacing the transmission and other parts.

Jul 11, 2025

THIS CAR HAS LESS THAN 2,500 MILES ON IT, AND IT FAILED TO GO INTO GEAR WHEN PULLING OUT ON A MAJOR HIGHWAY. WHEN IT DID SLIP INTO GEAR, IT WOULD ONLY GO 10 MPH THE WHOLE WAY HOME. MULTIPLE ALERTS WERE SENT TO MY PHONE; SEE BELOW FOR SPECIFIC ALERT INFO. THE DEALERSHIP SAID IT WAS A LOOSE WIRE AFTER TELLING ME THEY WOULD REPLACE THE CAR, AND OVER 60 SENSORS WENT OFF. ALERTS: SERVICE ENGINE WARNING POWERTRAIN MALFUNCTION REDUCED POWER PRE-COLLISION ASSISTANCE NOT AVAILABLE

Jan 17, 2025

SERVICE BRAKES

1 complaint

• What component or system failed or malfunctioned, and is it available for inspection? The brake system on my 2024 Ford Bronco Sport failed to respond for approximately 2–3 seconds after I pressed the brake pedal. This occurred immediately after freeing my foot from underneath the gas pedal while cruise control was active. The vehicle is available for inspection. • How was your safety or the safety of others put at risk? The vehicle did not slow down when the brake pedal was fully pressed, causing me to enter an intersection while other vehicles were turning. I had to swerve to avoid a collision, but another vehicle entered my path and a crash occurred. The braking delay directly increased the risk of a serious accident. • Has the problem been reproduced or confirmed by a dealer or service center? UNKNOWN. I have not yet had a dealership or service center attempt to reproduce or diagnose the issue. • Has the vehicle or component been inspected by the manufacturer, police, insurance, or others? The accident was documented by police and insurance, but the mechanical issue itself has not yet been inspected for cause. • Were there any warning lamps, messages, or symptoms prior to the failure? When did they appear? There were no warning lights, messages, or prior symptoms before the brake failure. The brakes simply did not respond when pressed. • Description of the incident: While traveling northbound on Sterling Ave approaching Truman Rd, the light turned yellow. I attempted to brake, but my foot was caught under the accelerator due to cruise control being engaged. After freeing my foot, I pressed the brake firmly, but the brakes did not respond for approximately 2–3 seconds. I swerved left to avoid turning traffic and sounded my horn. Another vehicle continued its turn and my front passenger quarter panel struck its rear passenger quarter panel at about 15 mph. The brakes only began functioning after the vehicle jerked from evasive steering input.

Nov 26, 2025

Crash: 1

UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM

1 complaint

At least 6 times now my gas guage has plummeted from 60+ miles to 6 then 2 and none in less than a mile. Thus has left me standed after midnight on the side of the highway and other various places. I had to use the road side help ford offered. It happens often and doinng deliveries this is very scary for me. I never know how much gas i have. I feel like im constantly putting in gas. I looked up the symptoms and found on reddit quite a few people experience the same. This could be very dangerous to me and other drivers constantly getting stranded on side of road or in the middle of the road. This is a new car im Paying alot of money for. And should feel as safe as possible while driving

Nov 20, 2025

POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

1 complaint

Powertrain malfunctions have occurred on 12/17/24, 4/11/25 and 10/5/25. Powertrain malfunction and yes. The car would not accelerate and someone could of ran into me, I could of been killed or badly injured and same for any other occupants in the either vehicle. Yes. Yes. The messages appeared on 12/17/24, 4/11/25 and 10/5/25.

Oct 07, 2025

VEHICLE SPEED CONTROL

1 complaint

I don’t know the exact name of the system that failed but my Bronco would not accelerate after making complete stops. When I would press on the gas pedals to move from a stopped position the Bronco would move very very slowly which in turn almost caused me to have over 3 car accidents as when I would press the gas to move from a stopping position it would move forward very slowly no matter who much pressure I would put on the gas pedal which in turn the oncoming cars almost hit me. I took the Bronco to the dealership and they said they had to reprogram the acceleration but that it could take up to 500 miles for the issue to be corrected. I believe from my experience this is dangerous and not safe! And should be addressed. This incident has happened several times not one.

Oct 03, 2025

ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

1 complaint

I reached out to ford due to my 2024 bronco sport overheating and running hot. During the time of that complaint I was advised that my bronco currently has a recall that the fuel tank needs to be replaced but it is currently being deemed as non safety and will only be addressed if the vehicle is in for service. I was also advised that due to this recall it is currently a part of fords customer satisfaction program. Anything fuel related should be deemed as a safety recall considering fuel is a flammable chemical. I have requested a buy back as I no longer feel safe operating the vehicle or comfortable transporting my daughter in the vehicle as it aligns too closely with the known fuel safety recall currently present on some 2021-2024 bronco sports.

Sep 05, 2025

POWER TRAIN,UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM

1 complaint

I have contacted ford directly and they still have not gotten a remedy for the unrepaired recall. My spouse and I went on a road trip that was 20 hour trip in total. They told us to keep driving it until it catches on fire because they did not have a remedy for it yet. We had just taken it in for an oil change and had them look the vehicle over due to the rpms keep jumping up even when going at low speed. The vehicle keeps loosing power and shakes when at idle or even when it starts up. We told ford about the smell of fuel or something when we walk by the hood of the vehicle and they said there was nothing wrong with it and that they didnt notice or smell anything when they did the oil change. When we talked to ford about our concern with the vehicle and that were were afraid to drive it especially since we have a baby and that we were told to continue driving it until it catches fire. We have a 9 month old who is in the vehicle daily due to having to go daycare. i am afraid for him being in the vehicle and it catching on fire or anything and not having enough time to get him out of the vehicle. Something needs to be done pronto or a law suit will be brought up

Sep 02, 2025

POWER TRAIN,UNKNOWN OR OTHER,ENGINE

1 complaint

Vehicle is having trouble with moving, when press on gas pedal it does not really want to move. When sitting at idle vehicle shakes really bad. can hear a really bad tick when driving vehicle. noticed that when driving the vehicle has been shaking really bad. Rpms have also been shooting up high when barely going up to speed.

Aug 15, 2025

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM

1 complaint

When coming from a stop at a traffic light vehicle losses power for approximately 15-20 seconds. This puts the driver of the vehicle, passengers, and other vehicle drivers operating on the roadway in danger of a major collision, possible bodily harm or even death. We have twice taken the vehicle to our dealership, where we purchased the vehicle; in order to fix the recall and we have had no success in gaining a remedy for the issues. The vehicle was seen twice by the Chandler, Arizona Earnheart Ford service department. There were no warning signs before the incident and they started appearing soon after the purchase of the vehicle. We have notice that the hotter it is outside the more frequent the loss of power occurs.

Aug 09, 2025

FUEL SYSTEM, GASOLINE

1 complaint

The contact owns a 2024 Ford Bronco Sport. The contact received a Carfax notification that the VIN was included in NHTSA Campaign Number: 25V467000(Fuel System, Gasoline); however, the part to do the repair was unavailable. The dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue, but was unable to provide an anticipated date for the parts' availability. The contact had not experienced a failure.

Aug 05, 2025

STEERING,SUSPENSION,SERVICE BRAKES

1 complaint

Chattering/screeching from right side of the car. Near tires. Took it in and showed example to technician and he heard it. Comes when turning right or backing up right slowly. They discovered it was the rear differential unit and it will be in the shop for 1-2 weeks.

Jul 29, 2025

VISIBILITY

1 complaint

The contact owns a 2024 Ford Bronco Sport. The contact stated that while the vehicle was parked outside, the front windshield cracked. The front windshield had a long horizontal crack. There was no warning light illuminated. Upon inspection, the crack had started from the inside of the windshield. The vehicle was taken to the dealer where it was inspected. The contact was informed that the windshield had cracked due to stress from sun exposure. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 3,500.

Jul 15, 2025

UNKNOWN OR OTHER,VISIBILITY/WIPER

1 complaint

The vehicle was bought brand new in February of this year, 2025. Was bought and has been driven by my daughter who turned [XXX] this year. She went to camp and the vehicle sat behind the house till she got back. the vehicle and front windshield face west and is exposed to the summer sun from 11:30 till 8pm. When she got back and went to drive the car on [XXX], there was a large stress crack in the middle of the windshield. (will attach pictures if possible with this online form). I had my neighbor check his security camera to see if anyone had vandalized the vehicle or if there had been any large object fall on the vehicle. after reviewing his recorded video, we both saw that no one touched the vehicle and that nothing fell on the windshield during the time it sat. I contacted Ford Motor Co. and they instructed me to take it to the dealership and have them take a look and then submit a claim if they thought it was a stress crack from the sun. I took the vehicle in to the dealership on June 26, 2025 and was told I would hear updates over the next few days. Over a week went by and I had to call the service dept at Wyatt Johnson Ford in Nashville. The Assistant service manager stated that Ford Warranty was denying the claim and stated that something else must have caused the crack. The Assistant Manager told me that the technician had written that they believed it was a stress crack from sun exposure and had submitted photos that backed up that claim. Also, on the work order, the Assistant Manager also wrote that it was a stress crack from sun exposure. There is a deep, horizontal crack in the middle of the windshield that has no origination marks or indentations which one would expect from the way that Ford Motor Warranty is denying the claim. I have asked the Assistant Manager to resubmit the claim and I sent him the photos I had taken as soon as it was first noticed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Jul 09, 2025

ELECTRICAL SYSTEM,LANE DEPARTURE,BACK OVER PREVENTION

1 complaint

My backup camera one two separate occasions has not operated properly. First time it never showed a vehicle had come up behind me. Didn’t go off with any notice. I backed into a car. Second time a man with a cart walk behind as I was backing out no notice. There is a recall on review camera but not on my vin.

May 30, 2025

Crash: 1

LANE DEPARTURE,BACK OVER PREVENTION

1 complaint

The entire Advanced Drive Assistants Systems only works when it feels like it. Thankfully I haven't had any accidents yet..., but I have come very close to it three times. Especially when the lane system went down, it almost sent me into the car next to me.

May 14, 2025

VISIBILITY,UNKNOWN OR OTHER

1 complaint

I was driving down the highway, and my moonroof exploded. I thought something had exploded or someone had shot at me. No other cars were around me that could have caused something to pop up and hit the roof. I did take it to the dealership service where photos were taken and submitted for a possible claim on the warranty. I only have about 2000 miles on the vehicle. My first payment isn't even due yet. Ford warranty declined the claim. It looked like it exploded upwards leading me to think this was an installation or material issue. Glass that exploded out flew off the roof of the vehicle scratching it as it dragged along. This could have hit another driver if one had been following behind me. I am currently awaiting a callback from the insurance adjuster.

May 14, 2025

VISIBILITY/WIPER

1 complaint

The windshield on this vehicle is faulty. On online forms, others have commented on the same thing I am experiencing: the integrity of this windshield is so weak that within a couple months (sometimes just a few days) of having the vehicle, you can get multiple chips or cracks. On my last chip, I was driving on a Michigan highway at least 30 yards from other vehicles when something chipped my windshield. I've had the windshield chip while going 65mph on the high way, and also while my vehicle was at a standstill at a red light and the car in front of me pulled away quickly, kicking up debris. People often comment that they cannot afford to constantly keep up with the unending number of repairs needed to fix the windshield. As a result, they're driving with reduced visibility which impacts all drivers on the road. ADAS is built into the windshield- if cracks/chips occur in this area, the ADAS can become compromised. The windshield also contributes to the strength of the vehicle in rollovers- lack of stuctural integrtiy due to cracks/chips impacts that. Being an SUV that sits higher, the Bronco Sport is more prone to rollovers that lower sitting vehicles. Because the cost of replacing the windshield through Ford is so high (over $1000) many opt not to replace it or use a non OEM, aftermarket windshield which might not work as well with safety systems. This issue has been inspected by a Safelite auto glass technician - he remarked that this is extremely common with the Bronco Sport, this vehicle is one of the most common models he repairs. This component is available for inspection upon request.

Apr 16, 2025

STEERING,UNKNOWN OR OTHER

1 complaint

The steering is temporarily disabled when the vehicle is in the auto off/fuel saver mode. I had an approaching EMS vehicle that I was almost struck by because my vehicle was off due to that feature. The steering wheel was not responsive.

Apr 02, 2025

POWER TRAIN,SERVICE BRAKES,ENGINE

1 complaint

Upon attempting to start vehicle every warning indicator flashed in series across the screen and the SUV would not start nor was the vehicle lockable. Also, the rear door and access glass (where tools, safety equipment, and spare tire is located) could not be opened. The vehicle would not start and could not be placed in neutral to push the vehicle to a safe location. The manufacturer informed me a "failure to communicate" was indicated in their system. Had this occurred in an unsafe location such as on a highway or in a physically dangerous location occupants would be placed in danger from other moving vehicles and/or criminal activity. Operators of this model MUST 1.) Be able to place the vehicle in neutral when needed. 2.) Be able to manually open the rear liftgate and/or rear glass to obtain safety and repair equipment. 3.) Be able to manually lock the vehicle as needed to secure both occupants and contents. I have scheduled a maintenance visit/repair with an authorized Ford dealer in Joplin, Missouri to address multiple instances of "Loss of Communication" as reported to Ford Motor Corp.

Nov 21, 2024

ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

On [XXX], my 2024 Ford Bronco Sport spontaneously burst into flames while driven by my [XXX] son. Per a local bystander, there was smoke and fire observed around the undercarriage as he drove down the road. Multiple vehicles began honking while stopped at a red light. A driver alerted my son of the fire. He was able to evacuate along with his [XXX] sister. As they were fleeing to the median of an active highway, the vehicle burst into flames. After several explosions the vehicle continued to burn and melt until the fire dept extinguished the flames. Prior to spontaneous combustion, there were no symptoms of gas leaks or error messages. Nor were there any fluid leaks. There were no error messages or signs of vehicle distress even while my children were driving & engulfed in flames. If bystanders had not flagged down my son, my children may have still been inside the vehicle when the fire & explosions consumed them. The fire department ultimately inspected the vehicle for damage. I am still awaiting their report. Initial conversations on the scene indicated an engine fire. On June 11th, my insurer commissioned an engineer to inspect the vehicle for causation. No report currently available. The vehicle was brand new; purchased just 6 weeks ago. At the time we purchased, 2022 & 2023 models had an open safety recall for fire risk due to a fuel injection defect. There were no reported design updates for the 2024 model. Nor were the recall fixes recommended in Feb 2024 installed on my Bronco purchased late April. It is my position that both Ford & the dealership knew or should have known the 2024 models would have the same defect and fire risk. Disturbing they sold their defective vehicle to my family. The dealership claims no responsibility or obligation to disclose risks. Ford refuses to speak with me given total loss status. My only recourse now is through my insurance. My children remain traumatized by their near death experience. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Jun 12, 2024

Fire: 1

POWER TRAIN,ELECTRICAL SYSTEM

1 complaint

The contact owns a 2024 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number 24V267000 (Electrical System, Power Train) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

May 15, 2024

LATCHES/LOCKS/LINKAGES

1 complaint

The contact owns a 2024 Ford Bronco Sport. The contact stated that the driver's side front door locked without unintendedly. There were no warning lights illuminated. The vehicle was taken to the local dealer, who was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 300.

Mar 06, 2024

2024 FORD Bronco Sport Problems & Complaints

Complaints by Component

Frequently Asked Questions

How many problems does the 2024 FORD Bronco Sport have?

What are the most common problems with 2024 FORD Bronco Sport?

Where does this 2024 FORD Bronco Sport problem data come from?

Other Years - FORD Bronco Sport

Other FORD Models

Similar Brands