2002 FORD Crown Victoria Problems & Complaints
Real owner complaints and problems reported to the National Highway Traffic Safety Administration (NHTSA). View common issues by component.
103
Complaints Reported
Complaints by Component
POWER TRAIN
11 complaints
VEHICLE TRANSMISSION FAILED AT 75,000- WE HAD TAKEN THE VEHICLE IN 2 SEPARATE OCCASIONS THE FIRST YEAR OF OWNERSHIP CONCERNING THE TRANSMISSION BUT WAS ADVISED NOTHING WRONG. *TR
Nov 13, 2007
BEGINNING OF 2006, I PURCHASED MY USED 2002 FORD EXPLORER. AROUND 70,000 MILES, ABOUT 9 MONTHS LATER, THE ROARING NOISE IN THE REAR WAS UNBEARABLE. I PUT ALL NEW TIRES,I PUT ALL NEW BRAKES THINKING THIS WAS CAUSING THE NOISE. FINALLY I WENT ONLINE TO FIND THE MANY, MANY COMPLAINTS ABOUT THE REAR END NOISE. I CALLED FORD CUSTOMER SERVICE AND THEY SAID THERE WAS NO RECALLS, EVEN THOUGH THERE ARE MANY COMPLAINTS ON THIS ISSUE, BECAUSE IT IS NOT CONSIDERED A SAFETY ISSUE. THEY SUGGESTED I HAVE IT DIAGNOSED AT A FORD DEALERSHIP. ON 10/20/07, I HAD THIS DIAGNOSIS DONE, AND WAS TOLD IT WAS THE REAR AXLE DIFFERENTIAL AND WAS ADVISED NOT TO DRIVE, OR DRIVE AS LITTLE AS POSSIBLE BECAUSE IT COULD CEASE UP WHILE DRIVING, AND CAN BE A SAFTEY ISSUE IF UNIT FAILS. THE COST OF THIS REPAIR, PARTS AND LABOR IS ABOUT $1200. IS FORD WAITING FOR THIS TO CEASE UP, CAUSING INJURIES OR DEATHS BEFORE THEY DEEM IT A SAFTEY ISSUE, AND RECALL THESE VEHICLES FOR REPAIR. I CANNOT AFFORD TO REPAIR MY VEHICLE AT THIS TIME AND NEED MY VEHICLE. *TR
Nov 01, 2007
WHILE ATTEMPTING TO SHIFT FROM REVERSE TO DRIVE, THE GEAR SHIFTER ON THE COLUMN BROKE IN 1/2 WHILE PASSING INTO THE NUETRAL POSITION. BROKEN PIECE IN POSSESSION. TRUCK WAS THEN STUCK IN NUETRAL WITH SHIFTER HANGING BY A WIRE. FOUND 2ND 2002 EXPLORER AT DEALER # 2 WITH GEAR SHIFTER BREAKING IN 1/2. *TR
Oct 23, 2007
I BOUGHT A USED 2002 FORD ESCAPE 2 MONTHS AGO AND IT WAS CARFAXED AND ALL AND NOTHING WAS WRONG. THREE WEEKS AGO THE ENGINE WOULD STALL OUT WHEN I STARTED THE VEHICLE OR WHEN I WAS DRIVING, I THOUGHT IT WAS BAD GAS, SO I FIXED IT. THEN IT HAPPENED AGAIN AND I THOUIGHT IT WAS THE BATTERY, SO I FIXED IT. I WAS FRUSTRATED AND WHEN IT HAPPENED AGAIN ON OCT. 3RD, 2007 IN THE MIDDLE OF A 7 LANE HIGHWAY. I WAS SCARED AND UPSET, AND I ENDED UP TAKING IT IN AGAIN! WE FOUND OUT THAT THERE IS A RECALL ON 2002 FORD ESCAPES WITH 3.0L V6 ENGINES FOR THE PCM ON DECELERATIONS BELOW 40 MPH BECAUSE OF FUEL-AIR MIXTURES BEING SENT TO THE ENGINE. IT WAS ISSUED IN APRIL OF 2004. I CALLED FORD MOTOR COMPANY, MY DEALER THAT I BOUGHT THE VEHICLE FROM, AND ANOTHER DEALER CLOSE TO ME; THEY ALL SAID THAT THERE WERE NO RECALLS ON MY ESCAPE. I LOOKED IT UP MYSELF AND THEY WERE CORRECT, BUT IF THIS RECALL WAS ALREADY FIXED THEN IT WAS OBVIOUSLY NOT FIXED CORRECTLY BECAUSE THE EXACT DEFINIATION OF THE RECALL IS WHAT IS HAPPENING WITH MY ESCAPE. MY COMPLAINT IS THAT I THINK FORD NEEDS TO ACKNOWLEDGE MY EXCEPTION AND KNOW THAT THIS IS NOT BECAUSE THE ENGINE NEEDS TO "RE-PROGRAM" ITSELF FOR A FEW WEEKS. IT IS A RECALL AND I THINK IT NEEDS TO BE FIXED FOR FREE, LIKE IT IS SUPPOSED TO BE. I DON'T LIKE TO BE IN THE MIDDLE OF A 7 LANE HIGHWAY AND LOOSE CONTROL OF MY STEERING AND EVERYTHING WITHIN MY CAR. *JB
Oct 06, 2007
PULLED 2002 FORD EXPLORER INTO COVERED SPACE AT APARTMENT COMPLEX AND PROCEEDED TO PUT THE CAR INTO PARK. WHILE ATTEMPTING TO PUT THE CAR INTO THE PARK THE GEAR SHIFT BROKE OFF FROM THE STEERING COLUMN. I COULD NOT BELIEVE WHAT HAD JUST HAPPENED. EXCESSIVE FORCE WAS NOT USED AND NEVER IN MY WILDEST DREAMS DID I EVER IMAGINE THIS TYPE OF FAILURE ON A CAR. LATER I RESEARCHED THE PROBLEM ON THE INTERNET AND FOUND THAT THIS IS A COMMON PROBLEM WITH THE 2002 FORD EXPLORER. I CAN'T START THE CAR SINCE IT IS NOT IN PARK OR NEUTRAL. HAD TO HAVE THE CAR TOWED AND ACCORDING TO THE INTERNET THE REPLACEMENT PART IS BACK ORDERED UNTIL MID NOVEMBER. SO, FORD IS OK WITH HAVING A PRODUCT ON THE ROAD THAT I CANNOT DRIVE FOR 1.5 MONTHS BECAUSE OF A BAD PART? IT APPEARS THE BAD PART IS MADE OF ALUMINUM WHICH IS SHOCKING. WILL HAVE TO GET A RENTAL FOR THE ENTIRE TIME I AM WITHOUT THE CAR. THIS KIND OF FAILURE IS UNACCEPTABLE AND THERE SHOULD BE A RECALL ON THIS PROBLEM. *TR
Oct 03, 2007
+ 6 more complaints for this component
SUSPENSION
10 complaints
2002 FORD WINDSTAR REAR AXLE PROBLEM WE WERE DRIVING ON 78E AND WERE APPROXIMATELY 30 MINUTES BEFORE ALLENTOWN. ALL OF A SUDDEN WE HEARD A CRACK, SMELLED SMOKE, AND HEARD METAL SCRAPING. THE CAR STARTED FISHTAILING AND MY HUSBAND VIRTUALLY HAD NO CONTROL OF THE CAR AS THE WINDSTAR REPEATEDLY CROSSED 2 LANES AND ALMOST HIT THE MIDDLE BARRIER AND THEN FISHTAILED TOWARD THE OTHER SIDE. LUCKILY THERE WERE NO CARS OR TRUCKS IN FRONT OR IN BACK OF US AND WE WERE AT A SLIGHT UPHILL. FINALLY, MY HUSBAND WAS ABLE TO GAIN CONTROL OF THE VAN AND PULL OVER TO THE SMALL SHOULDER WHICH WAS BARELY BIG ENOUGH TO FIT THE VAN. WE CALLED 911 AND AAA. WHILE WE WAITED ON THE SIDE, WE FEARED THAT WE COULD GET HIT IN THE EVENT THAT A TRUCK OR CAR SWERVED TO THE SIDE. WE WERE SHOCKED TO FIND OUT THAT THE REAR AXLE WAS CRACKED AND THE REAR TIRES WERE CAVED IN. MY AUTO DEALER GILBOY IN WHITEHALL OFFERED TO TOW AND REPAIR THE PROBLEM, BUT ONLY AT MY EXPENSE. FORD EXPLAINED TO ME THAT THERE WAS NO COVERAGE FOR THIS SITUATION BECAUSE THE VEHICLE IS OUTSIDE OF WARRANTY AND THERE CURRENTLY IS NO RECALL FOR THIS PROBLEM. BOTH GILBOY AND FORD TOLD ME THEY WERE NOT AWARE OF THIS PROBLEM WITH THE REAR AXLE. I HAD 3 CHILDREN IN THE CAR, 2 OF WHICH WERE MY OWN. THIS WAS THE SCARIEST MOMENT OF MY LIFE AS I FEARED WHAT POTENTIALLY COULD HAPPEN. LUCKILY, SOMEONE FROM ABOVE WAS LOOKING AFTER US BUT I FEAR THE NEXT FORD WINDSTAR OWNER MAY NOT BE SO LUCKY. PLEASE DO NOT WAIT FOR SOMEONE TO GET KILLED BEFORE TAKING ACTION. PLEASE HAVE THE PROBLEM CORRECTED AS SOON AS POSSIBLE AND ALERT ALL FORD WINDSTAR OWNER OF THE SERIOUS POTENTIAL RISK. *TR
Aug 03, 2010
WHILE DRIVING MY 2002 FORD TAURUS I EXPERIENCED THE FAILURE OF BOTH FRONT COIL SPRINGS WHICH CUT OPEN LIKE A CAN OPENER ONE FRONT TIRES AND DAMAGED THE OTHER. I HAD TO HAVE BOTH TIRES AND SPRINGS REPLACED. IF I WAS TRAVELING MORE THAN 15 MPH I FEAR I WOULD NOT BE HERE TODAY.*CN
Jan 01, 2008
ALL FOUR WHEELS BEARINGS ON A 2002 FORD EXPLORER WITH ONLY 70,000 MILES HAD TO BE REPLACED. ONE INCIDENT INCLUDED A WHEEL FALLING OFF DUE TO THE FAILURE OF THESE BEARINGS. *TR
Nov 29, 2007
FRONT STRUT SPRING BROKE FOR NO APPARENT REASON. *TR
May 29, 2007
BOTH REAR COIL SPRINGS DEFECTIVE PARTS. FORD WAS WILLING TO HELP ME WITH THIS COST OF THE REPAIR. *AK
Apr 13, 2007
+ 5 more complaints for this component
FUEL SYSTEM, GASOLINE
9 complaints
IN MID APRIL 2005, AS I WAS DRIVING MY 2002 FORD EXPLORER HOME (HAD@32,000 MILES), THE CAR JUST DIED WITHIN 2 SECONDS. NO WARNING AT ALL. I LOST ALL POWER, THE STEERING WHEEL TIGHTENED AND THAT WAS IT. FORD TOWED THE CAR (AS IT WAS STILL UNDER WARRANTY) AND SAID THAT THE FUEL PUMP WENT AND THAT CAR SHOULD NOT HAVE EVEN STARTED FOR ME. THANK GOD MY 3 YOUNG CHILDREN WERE NOT IN THE CAR WITH ME AND THAT I WASN"T HIT FROM BEHIND. AFTER THEY "FIXED " THE CAR AND AFTER WE PAID $600 FOR A 30,000 MILE MAINTENANCE, 6 WEEKS LATER THE SAME THING HAPPPENS TO MY HUSBAND. HE'D JUST DRIVING ALONG, THE CAR LOSES POWER WITHIN SECONDS AND COMPLETELY DIES WITHOUT ANY WARNING OR EVEN ANY TIME TO PULL OVER TO THE SIDE OF THE ROAD!!! (THE CAR NOW HAS 33,500 MILES). IT IS CURRENTL STILL AT THE DEALERSHIP BEING "FIXED". EE FEEL LIKE WE'VE ESCAPED SERIOUS ACCIDENTS TWICE NOW, AS WE COULD HAVE SO EASILY BEEN HIT FROM BEHIND BOTH TIMES. NEEDLESS TO SAY, WE WILL NEVER PURCHASE ANOTHER FORD AGAIN.
Jun 08, 2005
WHEN STARTING THE VEHICLE A NOISE WAS HEARD COMING FROM THE FUEL TANK AREA. DEALER FOUND A LEAK IN THE NECK OF THE FUEL TANK WHICH LEAKED GASOLINE ONTO THE TIRES, AND THE REAR DRIVER'S SIDE BRAKES. ALSO, FUEL PUMP WAS FAULTY. *AK
Oct 06, 2003
PROBLEMS WITH FUEL INJECTORS CAUSED VEHICLE FIRE.*MR THE CONSUMER STATED HE WAS SERVICING THE R.V WHEN ALL OF A SUDDEN THERE WAS A SOUND UNDER THE ENGINE COVER AND THE VEHICLE WAS ON FIRE. IT WAS DETERMINED THE FUEL INJECTORS WERE LEAKING. (CHATEAU MOTORHOME ON A FORD CHASSIS) *JB
Oct 01, 2003
THE CONSUMER WAS CONCERNED WITH THE GAS TANK PROBLEM WITH THE 2002 CROWN VICTORIA. THE SERVICE MANAGER TOLD THE CONSUMER THAT THE CIVILIAN VEHICLES, AS OPPOSED TO THE POLICE AND TAXI MODELS, WERE NOT OF THE SAME DESIGN THUS NOT SUBJECT TO THE GAS TANK PROBLEM. *MR *SCC *NLM
Jun 02, 2003
THE CONSUMER STATED THAT FORD REFUSED TO INSTALL A PLASTIC SHIELD AROUND THE GAS TANK TO PREVENT THE FIRE HAZARD THAT EXISTS IN THESE VEHICLES. MR SCC
Mar 31, 2003
+ 4 more complaints for this component
ENGINE AND ENGINE COOLING
8 complaints
TL* THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. WHILE DRIVING 35 MPH AND PROCEEDING TO STOP AT A RED LIGHT, THE ENGINE STALLED AND THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS ABLE TO RESTART AFTER NUMEROUS ATTEMPTS. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE MANIFOLD WAS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 81,218.
Jan 06, 2016
THE ENGINE STALLED WHILE DRIVING, FOR NO APPARENT REASON. DRIVER (MY RETIRED MOTHER, AGE 72) HAD TO GET CAR OFF ROAD AND RESTART CAR TO CONTINUE. THE POWER STEERING DISABLED WHEN THE CAR ENGINE STALLED. THIS HAS HAPPENED MULTIPLE TIMES (2-3) OVER THE PAST MONTH, AND THE LOCAL FORD DEALERSHIP CANNOT REPLICATE THE PROBLEM AND IS UNABLE TO CORRECT IT. ON ANOTHER OCCASION THERE WAS A THUMPING NOISE AND THE CAR SLOWED CONSIDERABLY, BUT THEN PICKED BACK UP AGAIN. THE "ENGINE HEAT/THERMOMETER" LIGHT HAS FLASHED ALSO, BUT THE ENGINE TEMPERATURE HEAT IS NORMAL. I CONSIDER THIS A VERY DANGEROUS SITUATION FOR MY MOTOR IF IT WOULD HAPPEN IN A HEAVILY CONGESTED, HIGH TRAFFIC AREA AND COULD CAUSE A VEHICLE CRASHES. IT IS A VERY STRESSFUL SITUATION.
Nov 26, 2011
I HAD BEEN DRIVING 250 MILES OR SO AND DROVE DOWN A LONG WINDING INCLINE, AS THE ROAD FLATTENED OUT I HEARD A NOISE FROM THE ENGINE COMPARTMENT. THE NOISE SOUNDED LIKE A HOLE IN THE FIRST PART OF THE EXHAUST SYSTEM. I FOUND A SAFE PLACE TO PULL OVER AND TURNED OFF THE VEHICLE. THERE WAS A SLIGHT ODOR OF NATURAL GAS AS THIS VEHICLE IS FUELED WITH NATURAL GAS. AFTER THE ODOR PASSED, I OPENED THE HOOD TO FIND THAT THE #2 IGNITION COIL MOUNT WAS BROKEN, AND THE COIL AND SPARK PLUG ASSEMBLY WERE LOOSE IN THE SPARK PLUG WELL. MY INITIAL THOUGHT WAS THE SPARK PLUG HAD LOOSENED AND EJECTED. I ATTEMPTED TO RE-INSTALL THE SPARK PLUG BUT THE THREADS IN THE CYLINDER HEAD WERE INEFFECTIVE. THE SPARK PLUG HAD BLOWN OUT OF THE CYLINDER HEAD. I HAVE SUBSEQUENTLY FOUND OUT THAT THIS IS NOT AN UNCOMMON DEFECT FOR THESE FORD ENGINES. THE REPAIR INVOLVED REAMING AND TAPPING THE SPARK PLUG HOLE AND PLACING AN INSERT IN THE HOLE. THE SPARK PLUG COIL HAD TO BE REPLACED TOO. THE REPAIR COST WAS $450 AND THE REPAIR SHOP WARNED THAT THIS MAY HAPPEN AGAIN. THIS IS A DESIGN DEFECT THAT COULD POTENTIALLY BE DANGEROUS UNDER DIFFERENT CIRCUMSTANCES. IF I WAS NOT ABLE TO STOP IN A SAFE PLACE FAIRLY QUICKLY, THERE COULD HAVE BEEN MORE FUEL AIR MIXTURE ACCUMULATION UNDER THE HOOD AND SINCE THE SPARK PLUG WAS STILL OPERATIVE, AN IGNITION SOURCE WAS PRESENT TOO. *TR
Sep 03, 2011
JUST CRUISING THROUGH A PARKING LOT ON MY WAY INTO WORK AND HAD A SPARK PLUG BLOWOUT. DAMAGED THE SPARK PLUG COIL AS WELL. HAD TO BUY A NEW COIL, AND A HELICOIL KIT TO RE-TAP THE SPARK PLUG HOLE. *TR
Apr 12, 2008
TL*THE CONTACT OWNS A 2002 FORD FOCUS. WHILE DRIVING APPROXIMATELY 5 MPH IN DRY CONDITIONS, THE VEHICLE STALLED. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE IMMEDIATELY AFTERWARDS NOR ON THE FOLLOWING DAY. THE VEHICLE WAS TOWED TO AAA FOR A DIAGNOSIS. THE CONTACT STATED THAT SHE IS EXPERIENCING THE SAME FAILURE AS NOTED IN RECALL # 06E056000 (FUEL SYSTEM, GASOLINE). THE CURRENT AND FAILURE MILEAGES WERE 106,000.
May 30, 2007
+ 3 more complaints for this component
VEHICLE SPEED CONTROL
8 complaints
1) I NOTICED THAT MY RPMS WERE NOT RETURNING TO NORMAL AND MY VEHICLE WAS UNABLE TO STOP COMPLETELY. 2) I OWN A 2002 FORD EXPLORER XLS 4X4 WITH THE SOHC 4.0 LITER ENGINE. THE THROTTLE CABLE STUCK IN THE OPEN POSITION CAUSING THE ENGINE TO SURGE UNCONTROLLABLY AT APPROXIMATELY 5000 RPMS. I HAD TO TURN OFF MY IGNITION TO AVOID CRASHING THE VEHICLE INTO NEARBY TRAFFIC. OTA HAS RECEIVED REPORTS OF THIS PROBLEM, NHTSA ACTION NUMBER: PE05037, BUT CLOSED THE CASE ON NOVEMBER 2, 2005. THIS IS A SERIOUS DEFECT THAT COULD HAVE RESULTED IN A SERIOUS CRASH. I BELIEVE THAT OTA SHOULD ISSUE A RECALL FOR THIS PROBLEM AS IT DID FOR CAMPAIGN #03V280000. 3) I WILL BE CONTACTING FORD TOMORROW TO RESOLVE THIS PROBLEM. MY VEHICLE IS CURRENTLY NOT SAFE TO DRIVE. *TR
Jan 24, 2008
VEHICLE PARKED IN PARKING LOT AT 9:30P.M. SHERIFF WOKE US UP 2:00 A.M. BANGING ON WINDOWS STATING SUV WAS ON FIRE. 3 OTHER VEHICLES WERE DAMAGED BECAUSE OF FIRE. I AM BLESSED MYSELF AND MY CHILDREN WERE NOT IN SUV AT THAT TIME. ALSO DAMAGED PARKING AREA. *TR
Nov 28, 2007
DT*: THE CONTACT STATED WHILE TRAVELING 55 MPH THE CRUISE CONTROL WOULD NOT DISENGAGE. THE CONTACT TRIED TO DISENGAGE THE CRUISE CONTROL AT THE STEERING WHEEL. WHEN THAT DID NOT WORK, THE BRAKE WAS APPLIED. THE VEHICLE ACCELERATED AND THE BRAKE WOULD NOT STOP THE VEHICLE. THE VEHICLE CRASHED INTO SOMEONE'S YARD. THERE WERE NO INJURIES SUSTAINED AND THERE WAS A POLICE REPORT FILED. THERE WAS SUBSTANTIAL DAMAGE DONE TO THE CONTACT'S VEHICLE. UPDATED 03/03/06. *JB
Feb 13, 2006
DURING HIGHSPEED INTERSTATE HIGHWAY TRAVEL WITH CRUISE CONTROL ENGAGED, EVERY TIME CAR HIT A SHARP BUMP IN THE ROAD, THE CRUISE CONTROL WOULD DISENGAGE CAUSING UNEXPECTED DECELERATION, CAUSING DANGEROUS SITUATION FROM HIGHSPEED TRAFFIC APPROACHING FROM BEHIND. THIS IS A CONTINUEING, ONGOING PROBLEM.*AK
May 05, 2004
WHILE BRAKING, THE VEHICLE ACCELERATED WITHOUT WARNING. THE CONSUMER HAD TO SHIFT TO NEUTRAL TO DECELERATE THE VEHICLE. THIS PROBLEM HAPPENED THREE TIMES. *AK *JB
Feb 19, 2004
+ 3 more complaints for this component
SERVICE BRAKES, HYDRAULIC
7 complaints
TL*THE CONTACT OWNS A 2002 FORD EXPLORER. WHILE DRIVING ON AN UNPAVED ROAD, THE CONTACT'S HUSBAND STOPPED THE VEHICLE AND APPLIED THE PARKING BRAKE. HE THEN RELEASED THE BRAKE AND APPLIED THE ACCELERATOR PEDAL. HE NOTICED THAT THE BRAKES FELT LOOSE AND THE CONTACT EXITED THE VEHICLE. SHE DISCOVERED A PUDDLE OF BRAKE FLUID UNDERNEATH THE VEHICLE. THE VEHICLE HAS NOT BEEN TAKEN TO THE MECHANIC. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 82,063.
Jul 05, 2007
FLEET OF 15 POLICE CARS, CROWN VICTORIA HAD THE FRONT BRAKE, ROTORS AND PADS REPLACED EVERY 20,000 MILES. THERE IS A PREMATURE WEAR OF BRAKE PARTS. DEALER NOTIFIED. PLEASE SUBMITTED OTHERS VIN#.
Nov 20, 2003
CONSUMER PAID FOR ABS BRAKES, AND THE VEHICLE CAME WITH STANDARD BRAKES. DEALER STATED IT WAS A MISPRINT. CONSUMER FEELS VEHICLE MAY NOT STOP PROPERLY IN AN EMERGENCY.*AK
Jun 12, 2002
VEHICLE HAS STANDARD BRAKES, BUT CONSUMER PAID FOR ABS BRAKES. CONTACTED DEALER, AND THEY STATED IT WAS A TYPOGRAPHICAL ERROR. *AK CONSUMER IS REQUESTING A REFUND OR A NEW VEHICLE.*YH
Jun 11, 2002
THIS LINE OF VEHICLES ALSO HAS 2 OTHER MAJOR COMPLAINTS FROM MANY OWNERS, 1ST IS A PROBLEM WITH THE FRONT BRAKES SQUEALING THIS WAS IDENTIFIED IN THE 2001 MODEL YEAR, A TSB WAS ISSUED AND THE 2002 MODEL HAS THE IDENTICAL PROBLEM. THE SECOND ISSUE IS THE ENGINE RUNNING ROUGH AT IDLE. AGAIN A TSB WAS ISSUED BUT THE PROBLEM WAS NOT CORRECTED IN THE 2002 MODEL YEAR. THE MAIN PROBLEM THAT WAS REPORTED HERE WAS DUE TO THE BRAKE PEDAL SINKING TO THE FLOOR WHEN THE PEDAL WAS DEPRESSED. ADDITIONALLY, BRAKE FLUID WAS FOUND LEAKING FROM THE TOP OF THE MASTER CYLINDER RESERVOIR. *AK
Apr 13, 2002
+ 2 more complaints for this component
AIR BAGS
6 complaints
2002 EXPLORER XLT PURCHASED 1/03 WITH 37,995 MILES. NOW ONLY 39,996 I AM DISABLED AND DON'T DRIVE MUCH. HAD VEHICLE IN DUE TO WARRANTY OVER 11/26/07 TO CHECK THINGS OVER. WHEN I PICKED UP CAR AIR BAG WARNING LIGHT FLASHING. THOUGH IT WAS DUE TO THEIR WORK BECAUSE IT STOPPED. NEXT TIME USED VEHICLE LIGHT FLASHING THEN STAYED ON PERMANENTLY. TOOK TO DEALERSHIP AND THEY CLAIM IT THROWS A CODE #B2292, THEY ALSO SAID A BULLETIN OUT FROM FORD ON THIS #TSB03-11-03 ISSUED TO ALL MECHANICS - THAT THE PRETENSIONER SAFETY HARNESS BOTH NEED TO BE REPLACED (DEFECT). I ADVISED THEM I WILL DISPUTE THIS DUE TO THE FACT THEY ALSO STATED FORD MAY BE DOING A RECALL. I CLAIM VEHICLE FINE TILL THEY WORKED ON IT. PART COMES IN TOMORROW, THEY SAY IT SHOULD BE READY IN A FEW HOURS, AND COST IS AROUND $295.. PLUS TAXES. ALSO HAD TO HAVE A REBUILT TRANY DONE LAST YR. ON THE AIR BAG LIGHT - I READ ALL THESE COMPLAINTS AND I AM SHOCKED THAT FORD HAS NOT ISSUED A RECALL. THIS IS NUTS. WHAT IS SCARY IS ALL THE FIRE REPORTS. *TR
Dec 04, 2007
2002 EXPLORER AIR BAG LIGHT STAYS LIT CAME ON AND NEVER WENT OFF WAS WONDERING IF THERE'S A RECALL TO HAVE FORD FIX THERE MISTAKE. *TR
Aug 04, 2007
FRONT END CRASH WITH 2002 FORD CROWN VIC ON INTERSTATE 95 IN BALTIMORE COUNTY MARYLAND. THE PASSENGER AIR BAG DEPLOYED BUT THE DRIVERS SIDE AIR BAG DID NOT. PRIOR TO THIS ACCIDENT THIS MORNING THERE HAD NOT BEEN ANY INDICATION THAT THE AIR BAG SYSTEM HAD ANY PROBLEMS. THE DAMAGE WAS THE RIGHT FRONT FENDER, BUMPER, AND HOOD. THE VEHICLE HAD TO BE TOWED. *JB
Feb 28, 2007
I PURCHASED A 2002 FORD WINDSTAR 4 DOOR VAN, AND UPON IMPACT OF CRASHMY FRONT AIRBAGS DID NOT DEPLOY. THIS IMPACT WAS AT 50-55MPH. I WAS TOLD THE REASON MY AIRBAGS DID NOT DEPLOY WAS DUE TO MY SEATBELT LOCK WHICH BROKE FROM THE IMPACT. ALSO NOW MY TRANSMISSION IS STALLING AFTER THE REPAIRS WERE MADE BUT THEY SAY NO RECALLS HAVE BEEN MADE ON THIS PROBLEM EITHER, BUT ACCORDING TO MY INSURANCE COMPANY IT IS A PROBLEM NOT ONLY WITH MY VEHICLE BUT SEVERAL OTHER PEOPLE HAVE REPORTED TOO.
Mar 24, 2005
AIR BAG DID NOT DEPLOY ON DRIVERS SIDE OF CAR AFTER COLLISION, CHEST INJURES RESULTED, CAR TOTALED. *JB
Feb 12, 2005
+ 1 more complaint for this component
ELECTRICAL SYSTEM
5 complaints
I HAD DRIVEN UP A STEEP MOUNTAIN DIRT ROAD TO SERVE SOME LEGAL PAPERS, AFTER REACHING THE TOP, I CONTINUED DOWN THE OTHER SIDE TO THE ADDRESS I WAS LOOKING FOR. I THOUGHT I STARTED SMELLING SOMETHING BURNING, IT SMELLED ELECTRICAL. WHEN I ARRIVED AT THE ADDRESS, I STOPPED THE CAR AND SHUT IT OFF WHILE I WAS SPEAKING WITH THE RESIDENT. MY WIFE YELLED AT ME THAT THE CAR WAS ON FIRE, IT STARTED FILLING UP WITH SMOKE FAST, MY WIFE AND DOGS WERE STILL IN THE CAR. I OPENED THE DRIVERS DOOR TO POP THE HOOD WHILE MY WIFE STARTED GETTING THE DOGS OUT, I THEN NOTICED IT WAS MY FLOOR THAT WAS BURNING, JUST ABOUT UNDER THE GAS PEDDLE, A HOLE HAD BURNED THROUGH AND THE METAL WAS GLOWING RED WHERE THE PADDING HAD BURNED AWAY. I POURED A CUP OF COFFEE TO PUT THE FIRE OUT WHILE THE RESIDENT GOT SOME WATER FOR ME. THE PADDING AND RUBBER MAT HAD BURNED AWAY AND A HOLE ABOUT 3 INCHES LONG HAD MELTED AWAY FROM THE FLOOR BOARD. THE CATALYTIC CONVERTER IS DIRECTLY BENEATH THE HOLE BUT THERE DOESN'T SEEM TO BE ANY HOLES IN THE CONVERTER AND THERE IS A EMPTY SPACE ABOUT 1.5 - 2 INCHES FROM THE MELTED HOLE TO THE CONVERTER. WE LET EVERYTHING COOL DOWN BEFORE DRIVING HOME, HOWEVER THE ENTIRE WAY HOME, (49 MILES) WE WERE AFRAID THE CAR WAS GOING TO BURST INTO FLAMES. ONCE WE WERE BACK ON THE PAVED ROADS AND WERE ABLE TO DRIVE THE NORMAL SPEED LIMIT, THERE WERE NO MORE ISSUES NOR ANY FURTHER BURNING, JUST THE LINGERING SMELL. I LOOKED UP AND FOUND A RECALL FOR AN ISSUE IN THE SAME LOCATION HOWEVER THAT WAS FOR 2003 - 2005 VEHICLES. *JS
Dec 30, 2014
1. WHILE DRIVING ,LED CIRCUITBOARD ,( UNDER DASHBOARD)BURNED UP EMITTING SMOKE INTO THE PASSENGER COMPARTMENT. IT BURNED A ONE INCH HOLE IN THE CIRCUITBOARD PLASTIC COVER . 2. FAILURE,THE PART BURNED UP, IT MAY HAVE BURNED BEFORE ALSO,BECAUSE WE HAVE HAD A BURNING SMELL BEFORE. 3. CAR WAS PARKED,TURNED OFF FOR ABOUT ONE-HALF HOUR , THEN DRIVEN 6 MILES HOME.,NO ADDITIONAL SMOKE WAS SEEN AT THIS TIME. PART HAS BEEN REMOVED BY OWNER .OLD PART IS AVAILABLE,PART # F8VB-14A597-AB. FUSE DID NOT BLOW AND CAR IS DRIVABLE WITH PART REMOVED. I THINK THIS PART IS A COMPONENT OF THE FACTORY INSTALLED ALARM SYSTEM. *TR
Jun 18, 2009
THERE WAS A STRONG SMELL COMING OUT OF THE AIR CONDITIONER VENTS IN THE WARM MONTHS. THAT I DESCRIBE AS A URINE ODOR. THE DEALERSHIP INSTALLED A FAN IN THE AIR CONDITIONER THAT COMES ON 15 MINUTES AFTER THE CAR IS TURNED OFF TO DRY OUT THE AIR UNIT.
Apr 28, 2005
WHILE VEHICLE WAS PARKED A FIRE STARTED UNDER THE HOOD. VEHICLE WAS TOTALED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
Jan 05, 2005
REPLACED SPARK PLUGS AT 75000 MILES WITH BOSCH PREMIUM PLUGS. APPROXIMATELY 3 MONTHS LATER SPARK PLUG NUMBER 7 (3RD FROM FRONT ON PASSENGER SIDE) BLEW OUT, CAUSING DAMAGE TO THE CYLINDER THREADS. HELICOIL WAS INSTALLED AND NEW SPARK PLUG INSTALLED. APPROXIMATELY 3 MONTHS LATER SPARK PLUG NUMBER 6(SECOND FROM FRONT PASSENGER SIDE) BLEW OUT CAUSING THE SAME DAMAGE.*AK
Dec 21, 2004
STEERING
5 complaints
POWER STEERING STARTED CATCHING AND COULDN'T TURN THE STEERING WHEEL SMOOTHLY. HIT A CURB WITH MY TIRE AND ALMOST HIT ANOTHER CAR. STILL JAMMING BUT I DON'T HAVE ENOUGH MONEY TO TAKE IT INTO A DEALERSHIP. HELP! *TR
Jul 14, 2014
TL* THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. THE CONTACT STATED THAT THE STEERING FAILED AND THE WHEEL BECAME TIGHT. THE VEHICLE WAS REPAIRED BY THE CONTACT AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.
Sep 03, 2013
I PUT MY KEY IN, TURNED IT ON AND WENT TO SHIFT IN TO DRIVE AND THE SHIFTER CAME RIGHT OUT OF THE STEERING COLUMN. THE VEHICLE WAS IN BETWEEN GEARS.*CN
Jan 02, 2008
STEERING VIBRATES. *NLM
Mar 19, 2003
STEERING WHEEL/COLUMN IS NOT PARALLEL TO THE DRIVER. IT IS SLANTED SO THAT YOUR LEFT HAND IS FORWARD OF YOUR RIGH HAND,THEREBY GIVING THE PRECEPTION THAT YOU ARE AIMED/DRIVING TOWARD THE RIGHT SIDE OF THE ROAD. CHECKED ALL CROWN VICTORIA'S ON DEALER LOT AND THEY HAD SIMILIAR SETUP AND IN SOME VEHICLES THE SLANT WAS MORE THAN IN OTHERS. ALSO, IN SOME VEHICELS THE DRIVERS SEAT WAS OFF-SET FACING TOWARD THE RIGHT SIDE OF THE CAR. I CONSIDER THIS A SAFETY ISSUE BECAUSE IT COULD LEAD ONE TO OVER STEER OR OVER CORRECT DUE TO THE MIS-PRECEPTION OF WHERE THE VEHICLE IS ACTUALLY BEING GUIDED. SO FAR THE MANUFACTURER HAS NOT ADVISED ME OF WHY THE VEHICLE IS DESIGNED THIS WAY, BUT AGREES THAT IT WAS BUILT LIKE THIS FOR SOME REASON. HAVE NOT BEEN ABLE TO GET FORD ENGINEERS TO TELL WHY THEY DESIGNED THE STEERING COLUMN THIS WAY. LOCAL DEALER SERVICE CENTER HAD ADJUSTED MY VEHICLE'S STEERING COLUMN TO BE MORE PARALLEL TO ME, BUT IT IS STILL SLANTED AND AT TIMES MAKES STEERING A LITTLE CONFUSING. *AK
Apr 04, 2002
WHEELS
4 complaints
2002 FORD CROWN VICTORIA LEFT REAR WHEEL SEPARATED FROM THE VEHICLE. *KB THE VEHICLE WAS DAMAGED AS A RESULT OF THE WHEEL COMING OFF. OHIO TRAFFIC CRASH REPORT# 10-89-0577. *JB
Jan 03, 2008
TL*THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. THE CONTACT STATED THAT THE TIRES ON HIS VEHICLE CONSTANTLY DEFLATE. THE MECHANIC STATED THAT THERE WAS A LEAK OUTSIDE OF THE RIMS AND THAT THE FAILURE WAS CAUSED BY THE RIMS AND NOT THE TIRES. THE MECHANIC WAS UNABLE TO REPAIR THE RIMS. THE CURRENT MILEAGE IS 59,000 AND FAILURE MILEAGE WAS 15,000.
Jun 22, 2007
RECALL 03V279000 SUBJECT: STEEL WHEELS: AFTER HAVING ALL THE WHEELS REPLACED THE CONSUMER NOTICED THAT THE REAR WHEELS WERE CRACKED. WHILE DRIVING THE VEHICLE VIBRATED UNCONTROLLABLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE CONSUMER THAT THE WHEELS WERE CRACK AND NEEDED TO BE REPLACED. PLEASE PROVIDED FURTHER DETAILS. *JB
Aug 12, 2004
PARKESBURG BOROUGH POLICE DEPARTMENT VEHICLE. THE RIMS ON THE VEHICLE CRACKED WHICH CAUSED THE RIGHT FRONT TIRE TO DEFLATE. PLEASE PROVIDE DETAILS.*AK
May 29, 2003
STRUCTURE
4 complaints
THE FIBERGLASS PIECE ON THE HATCHBACK OF THE VEHICLE IS CONSTANTLY CRACKING AND FALLING OFF WHILE THE VEHICLE IS MOVING. THIS IS A ROAD AND SAFETY HAZARD, AS MY PIECE CAME OFF WHILE DRIVING 55MPH. I AM CONTINUOUSLY SEEING OTHER EXPLORERS OF THE SAME MODEL AND YEAR THAT HAVE THE SAME ISSUE. FORD NEEDS TO TAKE RESPONSIBILITY FOR THEIR DEFECTIVE PRODUCT AND CONDUCT A RECALL. FURTHERMORE, THIS FAULTY PIECE IS OFFERED AT A FORD DEALERSHIP FOR REPLACEMENT AT OVER $300! *TR
Nov 13, 2007
DOOR AJAR LIGHT COMES ON RANDOMLY, TURNING ON INTERIOR LIGHTS AND LOCKING AND UNLOCKING DOORS WHILE DRIVING. IN ADDITION TO BEING DISTRACTING, IT IS PARTICULARLY UNSAFE AT NIGHT TO SUDDENLY HAVE THE INTERIOR LIGHTS COME ON AND UNABLE TO KEEP DOORS LOCKED. FORD SAYS ISSUE IS A DOOR SENSOR, BUT CANNOT TELL WHICH ONE IS BAD. THIS USED TO HAPPEN OCCASIONALLY, NOW IT HAPPENS AT LEAST EVERY OTHER DAY. *TR
Oct 31, 2007
I HAD TAILGATE WINDOW REPLACED DUE TO A "RECALL" WHEN WE PICKED IT UP TODAY, FROM THE DEALERSHIP- FORD OTTAWA IL THE REAR TAILGATE( NEXT TO THE FORD OVAL ) WAS CRACKED 8 INCHS. THE DEALERSHIP SWEARS THAT THIS WAS THERE WHEN WE BROUGHT IN THE TRUCK AND REFUSES TO ADMITT FAULT. T HIS TRUCK HAD NO CRACK BEFORE IT WENT IN FOR THE FIX. *AK
Feb 18, 2005
FORD HAS STOPPED INSTALLING SPLASH SHIELD (P/N FSVY*8327*A) UNDER MOTOR OF CROWN VICTORIA. THIS CAUSES THE FAN BELT TO COME OFF WHEN IT IS RAINING. CAR LOSES ALL ACCESSORIES INCLUDING POWER STEERING/ ALTERNATOR, AND WATER PUMP. CAR CAN NOT BE DRIVEN OVER 4 BLOCKS DUE TO OVERHEATING. THIS WILL PLACE ELDERLY PEOPLE ON SIDE OF ROAD IN RAIN (OR THEY WILL CRASH BECAUSE THEY WILL NOT BE ABLE TO TURN THE CAR WITHOUT POWER STEERING). *AK
Feb 11, 2002
VISIBILITY
3 complaints
WE RECIEVED A RECALL NOTICE ON TWO OF OUR FORD EXPLORERS. IT WAS CONCERNING THE GLASS IN THE LIFT GATE. THE RECALL STATED THAT THE GLASS COULD FALL OUT AND INJURE THE PERSON OPENNING THE WINDOW. WE HAD THE RECALL DONE ON TWO OF OUR VEHICLES. ABOUT 90 DAYS AFTER WE HAD THE VEHICLE REPAIRED THE GLASS DID FALL OUT ON ONE OF OUR DETECTIVES. WE HAD THE WINDOW FIXED AND FORD CHARGED US 1029.67 FOR THE REPAIR. OUR CONCERN IS TWO FOLD. OBVIOUSLY THE ORIGINAL PROBLEM STILL PERSIST AND THE SAFTY ISSUE IS A FACTOR. ALSO WE FEEL THAT FORD SHOULD KNOW THAT THE PROBLEM IS STILL PRESENT AND STAND BEHIND THE REPAIR AND FIGURE OUT ANOTHER FIX. I HAVE GOTTEN NO WHERE WITH FORD LOCALLY OR AT THEIR CUSTOMER RELATIONS CENTER
Jun 09, 2005
THE REAR GLASS OF MY FORD EXPLORER XLT 2002 "EXPLODE" WHEN THE GLASS WAS ATTEMPT TO BE CLOSED. PIECES OF GLASS TRAVELED ABOUT 10 FEET FROM THE ORIGIN. NO ONE WAS INJURED. THE GLASS WAS COMPLETELY BROKEN WITHOUT AN APPARENT REASON. NOW I CAN NOT USE MY CAR DUE TO THE BROKENGLASS. A REPORT WAS FILLED WITH THE LOCAL POLICE IN ORDER TO MAKE A REPORT TO THE CAR INSURER. A NEW GLASS WILL BE BOUGHT AND THE PRICE IS ABOUT $1300 AND THE HALF REAR DOOR NEED TO BE PAINTED AT ABOUT $150 USD.*AK
Jan 30, 2005
DO YOU HAVE REASEARCH REGARDING REAR VIEW MIRRORS IN CARS, FIELD OF VIEW, DISTORTION OF OBJECTS IN MIRRORS, ETC. THIS IS FOR A RESEARCH PROJECT. THANK YOU.
Feb 15, 2003
EXTERIOR LIGHTING
2 complaints
TL* THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. THE CONTACT STATED THAT THE HEADLAMPS DID NOT ILLUMINATE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE LIGHTING CONTROL MODULE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 15V861000 (EXTERIOR LIGHTING); HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 197,000.
Aug 03, 2016
WHILE DRIVING THE LOW BEAMS WENT OUT ON CAR,20 MINUTES LATER HIGH BEAMS WENT OUT. ALL OTHER LIGHTS WORK PROPERLY, HEADLIGHTS HAVE NOT WORKED SINCE. CURRENTLY IN THE PROCESS TO REPLACE PART. *TR
Feb 07, 2009
SEAT BELTS
2 complaints
TL** THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE FRONT DRIVER AND PASSENGER SEAT BELT BECAME UNLATCHED SPORADICALLY. THE CONTACT MENTIONED THAT THE FAILURE COULD HAVE BEEN DIRECTLY RELATED TO NHTSA CAMPAIGN NUMBER: 01V227001 (SEAT BELTS). THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000.
Nov 07, 2014
TL* THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. THE CONTACT STATED THAT WHILE DRIVING 75 MPH, THE DRIVER'S SEAT BELT CAME UNDONE. THE CONTACT RE-SECURED THE SEAT BELT AND THE FAILURE RECURRED. THE CONTACT HAD TO PURCHASE A SEAT BELT EXTENSION IN ORDER TO KEEP THE SEAT BELT BUCKLED. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOT NOTIFIED OF THE ISSUE. THE MANUFACTURER WAS NOTIFIED AND INFORMED THE CONTACT THAT THE VEHICLE WAS OUT OF THE VEHICLE SAFETY WARRANTY AND HE WOULD HAVE TO REPLACE THE SEAT BELT HIMSELF. THE FAILURE MILEAGE WAS 40800.
May 29, 2012
EQUIPMENT
2 complaints
CONSUMER STATES THAT IT TOOK NATIONAL BUS AND SALES THREE MONTHS AFTER THE FIRST DELIVERY TO GET THE WHEELCHAIR FLOOR TIE DOWNS TO PASS INSPECTION, REAR HEATER WAS IN THE WRONG PLACE FOR ONE OF THE VANS AND THE TIE DOWNS WERE OF THE WRONG TYPE, CONSUMER ALSO STATES THAT A NEW TRACK WAS INSTALLED, HOWEVER IT WAS NOT RECESSED. *SLC
Jun 10, 2002
CONSUMER STATES THAT IT TOOK NATIONAL BUS AND SALES THREE MONTHS AFTER THE FIRST DELIVERY TO GET THE WHEELCHAIR FLOOR TIE DOWNS TO PASS INSPECTION, REAR HEATER WAS IN THE WRONG PLACE FOR ONE OF THE VANS AND THE TIE DOWNS WERE OF THE WRONG TYPE, CONSUMER ALSO STATES THAT A NEW TRACK WAS INSTALLED, HOWEVER IT WAS NOT RECESSED. THESE ARE FORD VANS USED TO TRANSPORT ELDERLY AND DISABLED PERSONS. *SLC
Jun 10, 2002
ELECTRICAL SYSTEM,STRUCTURE,SERVICE BRAKES
1 complaint
..
Aug 20, 2025
ENGINE
1 complaint
Driving down the roadway at 55 mph a spark plug in cylinder 2 blow out. The car started making a popping noise and started to lose power. After a while the car shut off. The car was able to restart and be driven home. Upon inspection by a mechanic they found the spark plug had came dislodged and shot out of the cylinder and caused damage to the cylinder head the ignition coil and fuel rail. A new Heli coil was installed. A year later while in Texas driving down the road around 35 mph car made a pop noise and shot a spark plug out of cylinder 5 cause the car to lose power and start smoking with a heavy smell of fuel. Car was stopped and inspected. Found a spark plug was blown out of cylinder 5 with damage to the ignition cylinder and fuel rail. repaired the heli coil and placed with new spark plug ignition coil and fuel rail. 2019 while driving down road at 75 mph vehicle makes a loud pop and starts to lose power. Upon inspection by mechanic find spark plug blown out of cylinder 1 with damaged ignition coil. Having mechanic is now replacing both cylinder heads on the engine.
Jan 24, 2022
ELECTRICAL SYSTEM,EXTERIOR LIGHTING
1 complaint
TL* THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. WHILE DRIVING APPROXIMATELY 45 MPH AND ATTEMPTING TO MAKE A TURN, THE TURN SIGNALS AND HEADLIGHTS FAILED TO WORK, EXCEPT WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT ALSO NOTICED THAT THE TAIL LIGHTS DID NOT WORK AND THE DASHBOARD WAS BLACKED OUT. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHO WAS UNABLE TO SCHEDULE THE VEHICLE FOR A DIAGNOSTIC EVALUATION. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND STATED THAT THERE WAS NO RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 38,000. UPDATED 10/06/16*LJ ** UPDATED 10/19/16*LJ *TR
Aug 30, 2016
STEERING,SERVICE BRAKES
1 complaint
BOUGHT THE CAR FROM A FELLOW FRIEND HE ADVISED ME THAT THE CAR HAS HAD A ISSUE WITH THE STEERING WHERE THE STEERING WHEEL HAS PLAY TO IT AND ITS VERY DANGEROUS WHEN I DRIVE OVER 50MPH IM SCARED I MAY CRASH CAUSE THE CAR MOVES LEFT TO RIGHT, AND THE ABS BRAKES HAVE A PROBLEM THE BRAKE JUMP WHEN I HIT THEM IDK WHAT TO DO IM LOW ON FUNDS AND I WANT TO KNOW IF THIS IS A DEFECT THESE CARS ARE KNOWN FOR STEERING AND BRAKES DEFECTS..... *TR
Sep 09, 2014
ELECTRICAL SYSTEM,VISIBILITY
1 complaint
POWER WINDOWS FRONT ELECTRIC WHEN YOU TOUCH REAR WINDOW BUTTON THE DRIVERS WINDOW GOES DOWN. *TR
Feb 15, 2012
SUSPENSION,ELECTRICAL SYSTEM
1 complaint
TL*THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. WHILE DRIVING APPROXIMATELY 45 TO 50 MPH ON NORMAL ROAD CONDITIONS PRESSURE WAS APPLIED TO THE ACCELERATOR PEDAL. THE "ABS" WARNING LIGHT INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL AND THE DRIVER WAS ABLE TO COAST INTO THE EMERGENCY LANE. THE WARNING INDICATOR REMAINED ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO CONFIRMED THAT THE FAILURE WAS RELATED TO THE REAR DRIVE SHAFT AXLE. NHTSA CAMPAIGN ID NUMBER 04V328000 (SUSPENSION;REAR) WAS RELATED TO THE FAILURE; HOWEVER, THE VIN WAS EXCLUDED FROM THE RECALL. THE VEHICLE IS IN THE PROCESS OF BEING REPAIRED. THERE WERE CONCERNS OF THE SAFETY RISK INVOLVED. THE FAILURE AND CURRENT MILEAGES WERE 120,000.
Aug 26, 2009
SERVICE BRAKES, HYDRAULIC,VEHICLE SPEED CONTROL
1 complaint
ABS AND BRAKE LIGHTS HAS CONTINUED TO BE ON AND CRUISE CONTROL HAS STOPPED WORKING. *TR
May 22, 2009
ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM
1 complaint
TL*THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. WHILE DRIVING BETWEEN 55-60 MPH ON NORMAL ROAD CONDITIONS, THE VEHICLE BEGAN TO HESITATE AND VIBRATE. IN ADDITION, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL AND REMAINED LIT UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING AND STATED THAT THERE WAS AN INTERNAL COIL SHORTAGE. THE MISFIRE CYLINDER 5, COIL PACK, AND SPARK PLUGS WERE REPLACED IN THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON A SEPARATE OCCASION FOR THE IDENTICAL FAILURE AND THE MISFIRE CYLINDER 7, COIL PACK, AND SPARK PLUGS WERE REPLACED AT THAT TIME. THE FAILURE MILEAGE WAS 67,425 AND CURRENT MILEAGE WAS 68,045. UPDATED 03-27-09 *BF UPDATED 03/31/09.*JB
Mar 10, 2009
ELECTRICAL SYSTEM,VISIBILITY,LATCHES/LOCKS/LINKAGES,EQUIPMENT
1 complaint
I HAVE SEVERAL ISSUES, BOTH BACK DOOR WINDOWS HAVE FALLEN OFF TRACK AND WON'T STAY UP. THIS HAPPENED IN SEPTEMBER OF 07 AND A FEW MONTHS LATER THE SECOND REAR WINDOW DID THE SAME. I HAVE TO USE CLEAR PACKAGING TAPE TO HOLD THEM UP. THE KEY TO THE IGNITION WILL NOT TURN UNLESS I USE SOMETHING WITH A HARD END AND TAP IT SEVERAL TIMES. WHEN THE IGNITION PROBLEM FIRST HAPPENED IN SEPTEMBER OF 2006 I CALLED FORD ROAD SIDE SERVICE AND THEY RECOMMENDED TAPPING THE KEY SEVERAL TIMES AND SAID THEY HAD A GROWING COMPLAINT OF THIS. MY TRUNK LOCK LATCH OFTEN GETS STUCK TOO. JAN OF 2003 THE RADIO SHORTS IN AND OUT, I NEVER KNOW IF IT'S GOING TO STAY ON. LASTLY THE PASSENGER REAR DOOR LOOK DOESN'T LATCH, I THINK THIS HAPPENED IN LATE 2003 OR EARLY 2004. *TR
Jul 23, 2008
LATCHES/LOCKS/LINKAGES
1 complaint
TL*THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. THE CONTACT OPENED THE HOOD, BUT IT FAILED TO OPEN AUTOMATICALLY. HE PLACED HIS HAND ON THE FENDER AND THE HOOD SUDDENLY FELL AND SLAMMED DOWN ON HIS HAND. THE CONTACT SUSTAINED SEVERAL BRUISES, CUTS, AND BLISTERS. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE FAILURE AND CURRENT MILEAGES WERE 56,000. UPDATED 03/18/08. *LJ THE CONSUMER STATED AT THE TIME OF THE INCIDENT THE HOOD WAS RAISED TO THE FULL CAPACITY AND VEHICLE WAS TAKEN TO THE DEALER. THE DEALER STATED STRUTS WERE REPLACED AT CONSUMER'S EXPENSE. UPDATED 03/18/08 *TR UPDATED 4/2/08 *CN UPDATED 04/02/08 *TR
Feb 28, 2008
SUSPENSION,AIR BAGS
1 complaint
I AM AN OWNER OF A 2002 FORD EXPLORER 2WD. AT THE BEGINNING OF OCTOBER THE VEHICLE STARTING MAKING A HORRIBLE NOISE. THE LOUD NOISE WAS COMING FROM THE REAR PASSENGER WHEEL. COME TO FIND OUT, THIS IS A MAJOR WHEEL BEARING ISSUE. I HAVE RECENTLY GOTTEN ONLINE AND DISCOVERED HOW MANY OTHER PEOPLE ARE ALSO HAVING THE SAME ISSUE. WHAT CAN WE DO TO GET THE FORD COMPANY TO BE HELD RESPONSIBLE FOR THIS VERY DANGEROUS DEFECT IN THEIR PRODUCT THAT YOU ARE SUPPOSED TO TRUST NOT ONLY YOUR LIFE BUT THE LIVES OF ALL YOUR PASSENGERS. HOW CAN COMPANIES CONTINUE TO SELL THEIR UNSAFE VEHICLES TO THE PUBLIC. IT IS ENOUGH TO HAVE TO WORRY ABOUT GETTING MY 1 YEAR OLD TO AND FROM HER NANA'S WITHOUT HAVING TO WORRY ABOUT GETTING HIT BY SOMEONE, BUT TO WORRY THAT ANY MOMENT YOUR VEHICLE CAN CAUSE A MAJOR ACCIDENT WITHOUT YOU EVEN BEING AT FAULT BECAUSE OF FAULTY PARTS. PLEASE, CAN SOMEONE WITH ANY KIND OF DECENCY DO SOMETHING TO GET THIS COMPANY TO RECALL EVERY VEHICLE WITH FAULTY PARTS. COMMON SENSE WOULD SAY IT'S THE RIGHT THING TO DO. *TR
Oct 29, 2007
INTERIOR LIGHTING
1 complaint
THE DOME LIGHT ON THE 2002 FORD ESCAPE 3.0L CAUSED BURNING ON THE SUNROOF SLIDING COVER WHEN THE COVER WAS OPENED. THIS HAS THE POTENTIAL TO STARTING A FIRE, ALTHOUGH NOW THEREWAS ONLY A SLOW BURN. *AK
Jun 20, 2007
SUSPENSION,TIRES
1 complaint
I PURCHASED A 2002 FORD TAURUS SES ON JULY 31,2005. HOWEVER I HAVE BEEN EXPERIENCING A LOUD SOUND WHEN DRIVING LIKE THE WHEEL IS WOBBLING, AND THIS CAUSES THE CAR TO DRIFT SUDDENLY ALMOST CAUSING A ACCIDENT. I'VE BEEN ALSO EXPERIENCING A BURNING SMELL COMING FROM THE VENTS IN THE VEHICLES WHEN THE HEAT WAS NOT IN USE. *JB
Aug 24, 2006
TIRES
1 complaint
DT*: THE CONTACT STATED THAT THE SPARE TIRE CABLE BRACKET THAT HOLDS UP THE SPARE TIRE FRACTURED AND COMPLETELY DETACHED. THE SPARE TIRE DROPPED FROM THE VEHICLE AND WAS HIT BY ANOTHER VEHICLE. THE DEALER AND THE MANUFACTURE WAS ALERTED BUT THE MANUFACTURER DENIED THE CLAIM.*AK
Jul 11, 2006
UNKNOWN OR OTHER
1 complaint
THE FORD CROWN VICTORIA'S WAS INVOLVED IN NUMEROUS COLLISIONS. *AK *JB
Feb 24, 2003
FUEL SYSTEM, OTHER
1 complaint
FORD CROWN VICTORIA POLICE INTERCEPTOR SAFETY. TS
Dec 17, 2002
SEAT BELTS,SEATS
1 complaint
CONSUMER STATES AFTER TESTING THE SHOULDER HARNESSES, THE FRONT HARNESS CAME OUT OF THE WALL WHILE INSTALLING STRESS TEST EQUIPMENT WITH ONLY THE TENSION TAKEN OUT OF THE CHAIN, THERE WAS NEVER A PULL APPLIED TO THE HARNESS, THE CENTER HARNESS HAD PREVIOUSLY CAME OUT OF THE VAN AND THE BRACKET HOLDING THE SEAT BELT ASSEMBLY PULLED OUT OF THE WALL, CONSUMER FOUND THAT THE UNIT WAS ATTACHED WITH AN ALUMINUM ANCHOR AND ONLY THROUGH THE FIBERGLASS WALL OF THE VAN, THAT IS WHY THE TESTS WERE BEING COMPILED. THE SEATS THAT WERE INSTALLED WERE WRONG. THESE ARE FORD VANS USED TO TRANSPORT ELDERLY AND DISABLED PERSONS. *SLC
Jun 10, 2002
Frequently Asked Questions
How many problems does the 2002 FORD Crown Victoria have?
The 2002 FORD Crown Victoria currently has 103 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.
What are the most common problems with 2002 FORD Crown Victoria?
The most common problems reported for the 2002 FORD Crown Victoria are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.
Where does this 2002 FORD Crown Victoria problem data come from?
All problem and complaint data for the 2002 FORD Crown Victoria comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.
Other Years - FORD Crown Victoria
2024 Problems
2023 Problems
2022 Problems
2021 Problems
2020 Problems
2019 Problems
2018 Problems
2017 Problems
2016 Problems
2015 Problems
2014 Problems
2013 Problems
2012 Problems
2011 Problems
2010 Problems
2009 Problems
2008 Problems
2007 Problems
2006 Problems
2005 Problems
2004 Problems
2003 Problems
2001 Problems
2000 Problems
1999 Problems
1998 Problems
1997 Problems
1996 Problems
1995 Problems
1994 Problems
1993 Problems
1992 Problems
1991 Problems
1990 Problems
Other FORD Models
'34
1500 Foldaway
A8513
A9513
A9522
Aerostar
Affordable Aluminum
Affordable Trailers
Aspire
AT8513
AT9513
AT9522
Similar Brands
ST
3,555 models
RS
3,484 models
NC
2,822 models
ND
2,385 models
Z
1,951 models
MOTO
1,583 models
NU
1,189 models
RC
1,122 models