2022 FORD E-350 Problems

Complaints Reported

Complaints by Component

STEERING

4 complaints

Received a notice on a "Customer Satisfaction Program 24N03" Instead of issuing a recall for the Hydroboost power steering pressure and jumper lines they instead extended the warranty. People have had their braking and power steering go out while driving and this is simply unsafe and unacceptable. They need to replace their faulty "quick connector" to a hard connector before people are injured. My dealership refuses to do this as it is not a recall. Thank you for your consideration

Jul 26, 2024

2022 FORD E-350. CONSUMER WRITES IN REGARD TO POWER STEERING SAFETY RECALL.

Nov 16, 2022

During early morning hours (approx. 2 am) of 10/09/22, while traveling westbound on I-70 through Utah at posted speed (80 mph) I hit a series of road repairs (patches) while in the right-hand lane, with the driver-side (left) front wheel. The front end of the vehicle shook violently, leaving limited control of steering which resulted in the vehicle drifting quickly into the passing (left hand) lane. Fortunately, no one was in the passing lane and control was regained, but only after rapid deceleration through hard braking. The incident was freighting to say the very least, and has resulted in driver distress when traveling over bridges with expansion joints, experiencing changes to road surfaces, and/or anticipating poor road surfaces. Driver anxiety is a direct result of this incident. The vehicle is a new Ford F-350 diesel 4WD with fewer than 2000 total miles at the time the incident took place. An internet search suggests a probable cause associated with a “death wobble”? But on a brand new vehicle? Makes no sense and is very concerning as apparently Ford has been aware of this problem for years? Ford customer service department was contacted (10/10/22) via phone, and a case number [XXX] provided. The Ford dealership through which the vehicle was purchased (Keller Ford in Hanford, CA) was contacted per the recommendation of the Ford customer service representative and the vehicle is scheduled to be left with the Keller Ford service department on 10/12/22. Why isn’t Ford required to notify owners of this phenomenon so that at a minimum operators are aware of the potential problem and are at least prepared for its occurrence? I have owned many Ford vehicles in the 45+ years I have driven, starting with a 1956 Ford F-100 I purchased in 1978. I general, I am happy with Ford products. But in this instance (my first purchase of a new vehicle) I am not. This problem needs to be fixed immediately! INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Oct 11, 2022

The contact owns a 2022 Ford E-350. The contact stated while driving 35 MPH uphill, the vehicle lost power steering functionality. The contact downshifted manually to slow the vehicle however while depressing the brake pedal, the vehicle failed to stop in a reasonable time. The contact stopped the vehicle while using the parking brake. The contact pulled over and had the vehicle towed to the dealer to be diagnosed. The contact was informed that the power steering unit needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 11,000. The VIN was unavailable.

Jun 15, 2022

POWER TRAIN

2 complaints

Hello, when I start my vehicle and leave it in park and idle the transmission makes a mechanical clicking noise. I went under the truck to try to find the source of the noise. When I was underneath I found that when the clicking noise is active the drive line coming out the rear of the transmission is trying to turn. It is rocking back and forth. This is what the clicking noise is. I tried it with the vehicle in Neutral also. Same result. The transmission is sending power to the driveline while in park and neutral. I have a video I can submit but this form won’t let me include a video. If you response to me through email I will attach it there

Jun 25, 2024

The car was put into Park. The driver got out to check the position of the vehicle in the parking space. While looking at the passenger side of the RV, the vehicle began to power in reverse. It knocked over and injured the driver and ran into a fence. The passenger reached over to stop the vehicle just before it ran into two other people.

Jul 17, 2023

Injuries: 1

STEERING,SERVICE BRAKES, HYDRAULIC

2 complaints

The contact owns a 2022 Ford E-350. The contact stated while driving 60 MPH and depressing the brake pedal, the vehicle failed to stop as needed. There was no warning light illuminated. The contact desperately depressed on the brake pedal and the vehicle eventually came to a complete stop. The vehicle was towed to the dealer and the mechanic stated that the power steering pump needed to be replaced, and that the vehicle was previously repaired under NHTSA Campaign Number: 22V089000 (Steering, Service Brakes, Hydraulic). The vehicle was repaired. The manufacturer was contacted but no assistance was provided. The failure mileage was 12,361.

May 09, 2023

The contact owns a 2022 Ford E-350. The contact stated that while driving approximately 65 MPH, the steering wheel became stiff and the vehicle would pull in either direction. Additionally, there was an abnormal odor inside the cabin of the vehicle. The contact then noticed that the brake pedal had to be pressed very hard in order to stop the vehicle. After stopping to inspect under the hood, the contact discovered a power steering fluid leak in the engine compartment. The vehicle was driven to the local dealer who diagnosed that the power steering pressure line had detached. The vehicle was not yet repaired. The manufacturer was not yet notified of the failure. The contact indicated that the vehicle was previously repaired under the NHTSA Campaign Number: 22V089000 (Steering, Service Brakes, Hydraulic). The failure mileage was 6,300.

Sep 08, 2022

FUEL/PROPULSION SYSTEM

1 complaint

On August 2, 2024 I was driving my 2022 Ford F-350 7.3L on the interstate when I experienced sudden loss of power, engine was sputtering, obviously not getting fuel in my opinion. Engine eventually quit, and I came to rest on the side of I 20/59. No check engine light or other warning lights were ever illuminated during this episode. After 10-15 minutes of attempting to start, the engine finally restarted and I continued approx. 50 miles to my home with no further issues. On Aug. 14, I took my F-350 to Town and Country Ford in Bessemer, AL. Their Service Dept ran several diagnostics, tested fuel pressure, ethanol content, checked for misfire issues and road tested. No problems were found. Odometer at the time was 26,183. In July 2025 I received a Recall Notice from Ford (NHTSA Recall 25V455) for possible loss of fuel pressure due to fuel pump failure. Today (December 8, 2025) I attempted to contact Ford to get an update on the Recall, was provided no updated information (automated system only, live person was not an option). Also contacted Town and Country Ford Service Dept. for any knowledge they may have, which was none as well. I do not drive the truck every day, primarily due to not wishing to get stranded far from a repair facility (current odometer 38,000). I am filing this complaint to hopefully expedite Ford's response to a problem they have been aware of for over a year if not longer, and certainly since July 2025. The absence of any updates is infuriating for an issue that could become catastrophic.

Dec 08, 2025

ENGINE

1 complaint

failures of Ford engine 7 .3L VS 350 and we have 67000 there have been multiple cases of this engine ceasing at this mileage,. The warranty should be 100,000 especially if its a fleet vehicle and used for purposes like fedex.

Sep 19, 2024

FUEL SYSTEM, GASOLINE

1 complaint

The contact owns a 2022 Ford E-350. The contact received notification of NHTSA Campaign Number: 22V925000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The dealer was contacted, and an appointment was scheduled; however, the contact was informed that the recall could not be performed and advised to contact a different dealer. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

May 31, 2023

SERVICE BRAKES,ELECTRICAL SYSTEM

1 complaint

I've had trailer brakes and lights not working off and on with my 2022 F350. They're aware of it and sent a recall. I went to have the recall performed this morning and the dealer told me that the "fix" for the recall also doesn't work and that they'll call me when the "new fix" is ready. Meanwhile, I'm getting into towing season and I'll be towing a large trailer across the country repeatedly with trailer brakes that might work or might not.

May 20, 2022

STEERING,SERVICE BRAKES

1 complaint

Without warning my brakes and steering failed on a Freedom Elite RV on a Ford Motor chassis. The vehicle only had 2396 miles on it at the time of occurrence. It turned out to be a pressure hose that broke. Luckily I was in a residential neighborhood with no traffic and driving very slowly when it happened. I shudder to think what would have happened on a hill or in traffic.

Dec 27, 2021

⭐

4.8/5.0

67 reviews

Frequently Asked Questions

How many problems does the 2022 FORD E-350 have?

The 2022 FORD E-350 currently has 13 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2022 FORD E-350?

The most common problems reported for the 2022 FORD E-350 are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2022 FORD E-350 problem data come from?

All problem and complaint data for the 2022 FORD E-350 comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.