How many problems does the 2018 FORD Expedition EL have?

The 2018 FORD Expedition EL currently has 309 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2018 FORD Expedition EL?

The most common problems reported for the 2018 FORD Expedition EL are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2018 FORD Expedition EL problem data come from?

All problem and complaint data for the 2018 FORD Expedition EL comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.

2018 FORD Expedition EL Problems

POWER TRAIN

83 complaints

The contact owns a 2018 Ford Expedition. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended, and the transmission shuddered abnormally and unexpectedly downshifted. No warning lights were illuminated. The vehicle was driven to the shoulder of the road. The vehicle was then towed to a dealer where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 129,617.

Jul 29, 2025

The contact owns a 2018 Ford Expedition. the contact stated that while driving at 65 MPH uphill, the vehicle lost motive power. The contact stated that the vehicle was sputtering, and the wrench symbol was displayed. There were no warning lights illuminated. The vehicle was taken to the local dealer and was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was repaired. The manufacturer was contacted about the failure and referred to the NHTSA Hotline for assistance. The failure mileage was approximately 135,000.

Jul 22, 2025

2 instances have occured while driving. Stored codes are P0562 Charging system voltage low and P07E6 Stuck in Park (6/6/2025) and P07E6 Stuck in Park (7/12/2025). I believe the issue may be related to TECHNICAL SERVICE BULLETIN - Momentary Neutral-Out Condition In Drive - 23-2120 Upon acceleration to pass a car, I heard a loud knock, lost power, let off the gas, an Engine failure error flashed on my screen, regained power and was then able to accelerate again. The potential cost could be $5,600 and potentially higher due to labor. Ford's have been plagued by transmission issues year after year. How many vehicles need to be affected before a formal defect investigation focused on the 10R80 transmission can be made.

Jul 21, 2025

Recall 24E13 was issued for my vehicle on 4/16/2025 and i had repairs done on my vehicle in march. this recall states that catalytic converters may be replaced unnecessarily and the dealership has agreed with me on this. Ford continues to deny me reimbursement for this issue and I paid +/- 3800 for this repair to be done when I am sure I did not need it now.

Jul 10, 2025

See attached document for complaint.

Jun 24, 2025

+ 78 more complaints for this component

ENGINE

53 complaints

The problem is with the cam phasers on the Ford Eco Boost 3.5 V6 Engine. Every morning when the vehicle has been sitting overnight and the engine is cool; the truck makes a loud rattle noise when starting. The rattle goes away within 2 seconds. There are tons of information online pertaining the cam phasers. Ford Motor company is very much aware of this problem on all 3.5 eco boost engines from 2017 through 2020. There have been occasions that if the cam phasers are not replaced there could be major damage to the engine. Knowing it took Ford 4 years for Ford to get it right, this issue should be a recall.

Jul 16, 2025

The contact owns a 2018 Ford Expedition. The contact stated while attempting to start the vehicle, there was an abnormal rattling sound coming from the engine. The contact had not contacted dealer or independent mechanic. The vehicle was not taken a dealer or an independent mechanic to be diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure and opened a case. The contact related the failure to Customer Satisfaction Program: 21N03 (Vehicles Equipped with a 3.5L GTDI - Engine Cam Phaser Replacement); however, the VIN was not included in the Customer Satisfaction Program. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 67,850.

Jul 07, 2025

My 2018 Ford Expedition previously underwent a recall repair for a known cam phaser defect at Fremont Ford in Lander, Wyoming. The cam phasers are part of the engine’s variable valve timing system and are critical for proper performance and safety. Despite the initial recall repair, the exact same issue has returned. I am now experiencing rattling noise at startup, reduced engine performance, and engine hesitation—symptoms consistent with the original defect. When I contacted the dealership, they told me that the issue would not be covered again because too much time has passed. This issue clearly indicates a recall repair failure, which poses a potential safety hazard due to timing chain slack and the risk of engine damage or stalling. Cam phasers are essential to the safe and reliable operation of the engine. I am requesting that NHTSA investigate whether this recall needs to be expanded or whether Ford should be required to cover failed recall repairs like mine.

Jun 23, 2025

After taking my car in for a service bulletin and being told that the noise that was happening in my car was just a noise, I found out that my cam phasers needed to be replaced out of warranty. Driving down the road my car had a decrease in power and could have resulted in a wreck as I was not able to speed up correctly on the interstate.

Jun 03, 2025

My car started having cam phaser issues and caused a decrease in my ability to increase speed when on the interstate. This could have resulted in injury.

Jun 03, 2025

+ 48 more complaints for this component

SUSPENSION

21 complaints

Front struts faulty. Drivers side blew and all the fluid leaked out and the passenger side was leaking. Unknown safety issue but the vehicle only has 42,000 miles and has never been off road. Still has original tires, shouldn’t struts last longer than tires? The problem was confirmed by my local Ford dealer. I paid $1467.72 to have them replaced which is ridiculous for a vehicle with such low mileage. In my research I have found that this may be a widespread problem but there has been no recall. No warnings.

Oct 04, 2024

The contact owns a 2018 Ford Expedition. The contact stated that on several occasions when the vehicle was started, there was a rattling sound coming from the engine compartment. The contact stated while driving on several occasions at various speeds, the body of the vehicle had shifted. The vehicle was taken to a dealer where it was diagnosed and determined that the passenger’s side front axle seal needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 70,000.

Aug 02, 2024

All 4 struts failed at approximately 46,000 miles. It is available for inspection upon request but for safety reasons I will have it fixed as soon as possible. It had been riding rough for a while and started sending my children flying around the backseat particularly the third row and grew much louder and jostling with every bump in the road. Last oil change at 43,000 miles it was recommended to replace rear struts due to leaking but I was waiting for a second opinion. When I took it in for an alignment after new tires were put on I made no mention of this to see what they said and sure enough all 4 struts were leaking and needed replaced as soon as possible at 46,000 miles. No warning lamps or messages. Problems first appeared around July 2022 and progressively got worse.

Mar 07, 2023

The contact owns a 2018 Ford Expedition. The contact stated while driving 65 MPH, the vehicle started bouncing without warning. The contact stated that after several seconds, the vehicle stopped bouncing. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the front shocks were leaking, and that both front shocks needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, and the contact was referred to the NHTSA hotline to file a complaint. The failure mileage was 17,000.

Feb 17, 2023

At approximately 30,000 the vehicle's suspension failed, leading to a very rough ride like a boat hitting waves, and at speed affects the ability to control the vehicle. The Ford dealer advised that all shocks needed replacing. The problem developed gradually over about six months. These or the original shocks on the vehicle, and their early failure is a defect and safety concern.

Oct 11, 2022

+ 16 more complaints for this component

ENGINE AND ENGINE COOLING

17 complaints

The contact owns a 2018 Ford Expedition. The contact stated that upon starting the vehicle, there was an abnormal cranking sound coming from the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer where the contact related the failure to Customer Satisfaction Program: 21N03 (Cam Phaser Replacement); however, the contact was informed that the vehicle was not covered under the program. The vehicle was not repaired. The manufacturer was made aware of the failure, and the contact was provided a case number. The failure mileage was approximately 80,000.

Jun 30, 2025

The contact owns a 2018 Ford Expedition. The contact stated that when the vehicle was started, there was an abnormal rattling sound coming from the vehicle. No warning light was illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The dealer was made aware of the failure; however, unofficially the failure was diagnosed as a failed cam phaser. The manufacturer was made aware of the failure and a case was filed. The contact referenced an unknown recall; however, the VIN was not associated with the recall. The contact was advised to take the vehicle to the dealer for a diagnostic test. Additionally, the contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was 82,708.

Jun 25, 2025

The contact owns a 2018 Ford Expedition. The contact stated that while starting the vehicle on several occasions, there was a fast-banging metallic sound coming from the engine compartment. The vehicle was taken to a dealer, where it was diagnosed that the cam phasers needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 110,000.

Apr 09, 2025

The contact owns a 2018 Ford Expedition. The contact stated that the vehicle was making an abnormally loud ticking sound on cold starts, while idling, and while driving. The vehicle was taken to the dealer, where the sound was associated to a cam phaser failure; however, the vehicle was not diagnosed or repaired. The contact related the failure to Ford Campaign Number: 21B10. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to verify whether the vehicle was covered. The failure mileage was approximately 122,000.

Apr 03, 2025

The contact owns a 2018 Ford Expedition. The contact stated that there was an abnormal clunking sound while starting the vehicle. The contact stated that while driving a undisclosed speeds, the engine overheated. The contact stated that there was an extremely loud knocking sound coming from the vehicle. The check engine warning light was illuminated. The contact stated that the failure was related to Customer Satisfaction Program: 21N03. The vehicle was taken to an independent mechanic who determined the failure was related to the cam phasers. The vehicle was taken to the local dealer, who confirmed there were no associated recalls. The vehicle was diagnosed, and it was determined that the water pump needed to be replaced. The water pump was replaced. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 40,000.

Dec 03, 2024

+ 12 more complaints for this component

UNKNOWN OR OTHER

16 complaints

On [XXX] my AC stopped working and there was a major burning smell. I took the vehicle in to determine the issue. The service advisor advised me that the motor blower had overheated and burned the wires completely causes a fire hazard. Later to find out there was the same recall under incident number 22S56, but my year vehicle was not included. I called Ford customer service and was told they have heard customers having the same issue with 2018s but has yet to be recalled. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Aug 05, 2025

When it is below freezing and there is snow/condensation on the door windows the door lock can get stuck/frozen closed. Many times the door will unlock and open to get in but once I get to my destination I can't get the door open to get out of my car. This has happened on all the doors at different times. We get stuck and I have to crawl out another door that will unlock. There isn't a way to manually pull the door unlocked because the knob goes into a hole so you can't pull it up. Also, sometimes when I run remote start the door will not unlock and open to get into the car. I also have children in car seats, this would be a major safety issue in an emergency if we couldn't get out.

Feb 10, 2025

Automatic transmission is causing slipped gears, harsh shifting, jerking, and hesitation. I am almost met with accident couple of times with my family. Whie driving car suddenly shift from 10 gear to 5th gear causing erratic behaviour. While waiting in the Signal for Green light, and when we press the accelerator. Car is not moving at all from first gear.erratically shift to 6th gear.

Jun 28, 2024

The large sunroof is made of cheap plastic mechanics and will no longer close as a plastic piece has come off the track. Causes safety issue. The vehicle is available upon request. The window not being sealed if turned over the passenger will be injured with glass shards or distracted while driving as the window will not close. The vehicle has not yet been inspected but is at the Ford Dealership being looked at. There were no other symptoms of the problem.

Jun 20, 2024

The Transmission is slow to respond leaving inhibited acceleration. Not being able to accelerate while pushing down on the gas pedal when entering the freeway is a major concern and could be costly to others life and mine. While making a turn during a green arrow, a collision is bound to happen. Dealer is currently reviewing vehicle. No warning lights for transmission present at time of transmission failures.

Jun 20, 2024

+ 11 more complaints for this component

EXTERIOR LIGHTING

16 complaints

Drl not workingg

Aug 03, 2025

The passenger DRL is only lit at at the top strip and not the rest of the strip.

Jul 11, 2025

Defective daytime running light, passenger side, that does not fully illuminate. I’ve noticed this on several of the same make, model, and body style (with the same DTRLs).

May 07, 2025

The passenger side day time running light led halo is partially not working-Daytime Running Light defective. Several customers affected for the same reason all over internet.

Mar 07, 2025

Daylight light led lighting is halfway off.

Feb 14, 2025

+ 11 more complaints for this component

POWER TRAIN,ENGINE

10 complaints

2018 Ford Expedition Max 4wd; For the last 4 years I have consistently (1-2x a year) brought this car into a ford dealership for the transmission failing to go into gear at random times while driving under normal conditions. Even though multiple TSB's had been sent out, they "couldn't replicate" or "no codes found" or "the transmission tech is 4–6 weeks out"... nothing was done. Twice while merging into on coming traffic the transmission has been stuck in a gear, will not accelerate or go, and the entire dash illuminates with all the flashing symbols. I'm just glad my children were not in the car with me. It was terrifying. Now, the week of May 18, 2025, I'm back for my annual transmission issue as it stalled on 4/26/2025, and I almost was hit by an 18 wheeler, the ford dealership said "you need a transmission overhaul, TCM reprogram, and there is internal failure, the CDF drum comes apart and Ford is aware they have a faulty seal." The total to fix is $8,214.25 and guess what, NONE of it is covered. I have kept my vehical serviced and always taken care of it. But I will have to pay the price to fix it, or worse if there is a car accident.

May 21, 2025

1. The issue involves the transmission and camshaft components of the vehicle. Despite the fact that both the transmission and camshaft were replaced by the Ford dealership after purchase in 2018, the vehicle continues to experience problems. These components have been inspected by the dealership, and the vehicle is available for further inspection upon request. 2. The vehicle’s loss of power during highway driving and while attempting to accelerate poses a significant safety risk. On several occasions, the vehicle has lost power while making turns or driving on the highway, nearly causing accidents with other vehicles. This has been a very frightening experience for us, as the sudden loss of power could have led to a collision. 3. Yes, the problem has been confirmed by the Ford dealership, which replaced the transmission and camshaft components. However, the vehicle continues to run roughly, indicating that the issues have not been fully resolved. These repairs were not covered under warranty, and we had to pay for them out of pocket. 4. The vehicle has been inspected by the Ford dealership multiple times. Despite the repairs, the problems persist. The vehicle has been regularly maintained and garage-kept. 5. There were no warning lamps, messages, or error codes indicating the problem before the failure. However, there has been a loud ticking sound when the vehicle is started and running, which started to occur after the initial repairs. The vehicle has had no other prior indicators to suggest the underlying issue. We purchased the vehicle brand new with only 11 miles on it it currently barely has 70k miles on it. We dropped the vehicle off at the beginning of August 2024 and didn't get it back until almost the end of October, with us needing to bring it back to the dealership for more checks/repairs in December of 2024. We have to pay out of pocket and are without a vehicle because of the constant issues and safety concerns. we can provide receipts and more docs

May 09, 2025

Cam phaser failure, yes, available for inspection. This disrupts the engine's timing and can lead to oil pressure issues as well as engine stalling or engine damage. Yes, confirmed by ford dealer. No, not been inspected by manufacturer or others. No warning lamps yet but the noise was the first indicator and it began about 6 weeks ago. My 2018 Ford Expedition is experiencing cam phaser failure. I had an extended warranty that i have not reached the mileage for yet but the date causes me not to be able to have it fixed under warranty. This is a very expensive repair and I am finding out more and more of these vehicles in this age range are having the same problems. I would ask that Ford be required to pay for this repair. I have reported this to Ford and received a case number of [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

May 08, 2025

The truck suddenly loses power while driving. Then goes back to normal. Most recently but not only time I lost power on interstate, the dash blinks see manual. I was almost hit by vehicle behind me as i was unable to continue accelerating. Similar recalls for my year and make of vehicle include powertrain control module reprogram for cam phaser rattle and automatic engine idle shutdown.

Feb 28, 2025

I brought my vehicle in for inspection and there is an issue with the cam phasers and timing. The cam phaser issue is a known Ford Expedition issue that they addressed and extended warranty coverage. I have been bringing my vehicle for routine maintenance, oil changes, tire rotations etc to both Koerner Ford of Syracuse, NY and more recently Dave Pirro Ford in Skaneateles, NY. I had an extended warranty that I purchased that recently expired. During many visits to the dealerships the cam phaser issue was never addressed even though it would have previously been covered under warranty and now is not. I would like to know my options as this issue is now going to cost over $6,000 to fix.

Sep 06, 2024

+ 5 more complaints for this component

WHEELS

7 complaints

The contact owns a 2018 Ford Expedition. While contact's son was driving at an undisclosed speed, the low tire pressure warning light illuminated. The contact's son drove the vehicle to the intended destination. The contact's son inspected the tires and determined that the front passenger’s side tire was cracked and needed to be replaced. The contact arrived at the location. The contact and son attempted to remove the lug nuts and bolts; however, the OEM provided lug removal tool did not fit the nuts and bolts. The vehicle was towed to the dealer where the contact was informed that in hotter states the nuts and bolts occasionally would become swollen, and the provided lug tool would not work as intended. The contact requested that all the nuts and bolts be replaced, to prevent the failure from reoccurring. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 90,000.

Jun 25, 2025

The wheel nuts on my vehicle are defective. The Ford Dealership had to replace all twenty-four of them for "swelling". Evidently, the design of these wheel nuts (Ford part number ACPZ 1012 M) makes it impossible to remove without destroying them because of their defective design. According to Ford Customer Care, these parts are considered wear items and are not covered under warranty. In my opinion, wheel nuts may be considered a safety item, should they fail or if they are not removeable with customary tools during roadside emergencies. I purchased this vehicle new in October 2018 and since then several Ford Dealerships have said they have issues installing and removing with these particular wheel nuts, and most are destroyed in the removal process. They have voiced their concerns to Ford with no remedy thus far. I am told these parts are also on various models of F-150 trucks. While I do not expect NHTSA to issue a recall for this issue, I would hope that a voluntary recall program could be enacted by Ford wherein these wheel nuts are replaced free of charge when service is performed requiring the wheels to be removed.

Jan 28, 2025

Lug nuts could not be removed using Ford's lug wrench. All lug nuts seemed to be slightly oversized preventing lug wrench from fitting. Had I been out on the highway needing to replace a tire, it would have required specialized assistance. I had to replace all lug nuts in order for lug wrench to be an option in the future. I do still have the old lug nuts.

Sep 16, 2024

The lug nuts swell and thus disable the lug wrench or any standard socket from removal. This has prevented me from changing tire or brakes because I can't remove the wheel.

Mar 26, 2022

When trying to change a flat, the factory provided lug wrench would not go onto the factory lug nuts. I was able to get to the tire shop and was advised of an on going issue with the ford lug nuts “swelling “ which in turn would not allow me to remove them to change the tire. After further digging there seems to be many many complaints of this same issue. It was recommended to purchase new ones that were not a two piece design as the OEM Ford ones are. I was told that this could and most likely would continue to happen and could even cause the wheel to come off in worst case scenario. I had to pay 195 dollars for a new set cause I had no other choice being on the road and away from home or a dealership

Mar 22, 2022

+ 2 more complaints for this component

STRUCTURE

5 complaints

When getting things out of the Rear Cargo area the Lift Gate has come down unexpectedly and hit Me in the head. Several times the Rear Lift gate randomly opens when exiting or entering the car. Has hit my spouse and has come close to hitting other person walking in back of the vehicle. The Lift Gate came open barely missing the vehicle parked behind it. Would of damaged both vehicles Renegade Super C $300,000 and the Ford Expedition $85,000 along with possibly pinning and injuring the person behind the vehicle. Took the vehicle to a Ford Dealer and they ran diagnostic tests and looked for any faults and found nothing. We feel like we are driving a ticking time bomb and just missing a bullet each time we go to use the vehicle. Need immediate attention-

May 03, 2022

THIS IS OUR SECOND WINTER WITH THIS VEHICLE AND BOTH SEASONS DURING WINTER TEMPERATURES THE RIGHT REAR DOOR WILL NOT LATCH TO STAY SHUT. WE HAVE SMALL CHILDREN THAT RIDE IN THE REAR OF THIS VEHICLE, SO THIS MAKES THIS MUCH MORE OF A CONCERN. MY HUSBAND IS A MECHANIC AND TRIES EVERYTHING TO MAKE IT WORK AND IT HAS BEEN A HUGE HASSLE. ESPECIALLY FOR SUCH A NEW, EXPENSIVE VEHICLE. THE VEHICLE IS STATIONARY WHEN THIS HAPPENS AS WE ARE UNABLE TO GO ANYWHERE WITH A DOOR THAT WILL NOT SHUT!

Dec 10, 2020

TL* THE CONTACT OWNS A 2018 FORD EXPEDITION. THE CONTACT STATED THAT BOTH VEHICLE REAR DOOR LATCH FAILED TO CLOSE SECURELY. THE CONTACT WHO WAS A CERTIFIED MECHANIC PURCHASED THE PART AT GRAHAM AUTO MALL DEALER, (1515 W 4TH ST, MANSFIELD, OH 44906) AND REPLACED THE LOCKING MECHANISM HOWEVER, THE FAILURE RECURRED. THE CONTACT STATED THAT THE FAILURE WAS MORE PREVALENT IN COLDER TEMPERATURES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED. THE FAILURE MILEAGE WAS APPROXIMATELY 125,000.

Feb 20, 2020

THE REAR WINDOW DEFROST CONNECTORS DETACHED FROM THE REAR WINDOW, WHICH MEANS THE REAR WINDOW DEFROST DOES NOT WORK AT ALL. ON TWO SEPARATE OCCASIONS, THE REAR WINDOW DEFROST SOLDER HAS DETACHED. THE FIRST TIME WAS THE DRIVER SIDE. I TOOK IT IN, AND OUR LOCAL DEALERSHIP FIXED IT WITH A GLUE-ON REPAIR KIT. THE SECOND TIME IT WAS THE PASSENGER SIDE. IT IS CURRENTLY IN WARRANTY JAIL AGAIN AT OUR LOCAL DEALERSHIP SO THEY CAN ATTEMPT TO FIX IT.

Jan 22, 2020

IN COLDER TEMPERATURES, THE ENTIRE INTERIOR DOOR MECHANISMS FREEZE UP AND DO NOT ALLOW THE PASSENGERS TO EXIT OR ENTER THE VEHICLE. MAJOR SAFETY ISSUE! THERE HAVE BEEN SEVERAL TIMES THAT I HAVE HAD TO CRAWL TO THE BACK SEAT TO GET OUT OF MY VEHICLE. WHAT IS GOING TO HAPPEN IN AN EMERGENCY SITUATION?

Jan 22, 2020

SEAT BELTS

4 complaints

The contact owns a 2018 Ford Expedition. The contact stated that while her husband was driving at 20 MPH, the front driver's side seat belt exploded, making a loud popping sound, and the seat belt tightened and pulled the driver back into the seat. Additionally, the automatic emergency braking system engaged, causing the vehicle to stop. No warning light was illuminated. The contact's husband stated that the cabin was filled with smoke and an electrical burning odor was noticed. The driver pulled over, but the seat belt had significantly retracted and was able to be unbuckled after several attempts. The contact’s husband sustained a seat belt mark on the left shoulder, but no medical attention was received. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and a case was filed. The contact was informed of that the VIN was included in NHTSA Campaign Number: 25V197000 (Seat Belts); however, the contact stated that the recall notification had not been received and the part to do the recall repair was not yet available. The failure mileage was approximately 26,600.

Aug 07, 2025

Injuries: 1

Went to leave for work and as I started my vehicle and pulled my seat belt to put it on and the seat belt pretensioner went off.

Jun 17, 2025

Injuries: 1

THE SEATBELTS ON THE OUTSIDE 2ND ROW SEATS WILL NOT FIT BIGGER PEOPLE BECAUSE ONLY THE LAP BELT PORTION OF THE ASSEMBLY IS TOO SHORT. THIS SEAT BELT INFLATED OVER THE VERTICALS PORTION OF THE BELT SO IT CANNOT USE AN EXTENDER. THE SOLUTION IS TO LENGTHEN THE LAP PORTION OF THE SEATBELT. TWICE, THIS VEHICLE HAD TO BE DRIVEN WITH PERSONS IN THAT SEAT WITHOUT A SEATBELT BECAUSE IT WOULD NOT FIT. INVESTIGATION REVEALS THESE SEATBELTS ARE MADE FOR TEENS, HOWEVER THEY SHOULD FIT ANYONE RIDING IN THE SEAT. WE ASKED FORD CUSTOMER SERVICE TO HELP SOLVE THIS PROBLEM, HOWEVER THEY QUICKLY CANCELLED OUR CASE. I CALLED AND RE-OPENED THE CASE. # CAS-21718846-M4J6B6. THE VEHICLE WAS IN MOTION WHILE THE TWO PERSONS WERE UNABLE TO USE THE SEATBELTS. NOTE: THE LAP PORTION OF THE SEATBELT IS NOT INFLATABLE, AND IS TOO SHORT, WHILE THE INFLATABLE PORTION IS THE VERTICALS PART AND IS PLENTY LONG AND WOULD FIT ANYONE. THE LAP PORTION NEEDS TO BE LENGTHENED.

Jul 02, 2019

AFTER CALLING 3 FORD DEALERS AROUND KANSAS CITY MO. THEY ALL TOLD ME THAT FORD DOES NOT HAVE SEAT BELT EXTENSION FOR 2018 EXPEDITION.

Aug 22, 2018

ENGINE AND ENGINE COOLING,ENGINE

4 complaints

The contact owns a 2018 Ford Expedition. The contact stated while driving at an undisclosed speed, there was a loud clanking sound coming from the vehicle with smoke coming from the engine compartment. The vehicle was taken to the dealer where it was diagnosed and determined that the heater hose and cam phaser had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 118,000.

May 27, 2025

The contact owns a 2018 Ford Expedition. The contact stated while starting the vehicle, there was a loud clanking sound coming from the vehicle. The check engine warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed with cam phaser failure. The vehicle had been taken to the dealer two previous times for unknown repairs. The vehicle was not repaired for the most recent failure. The vehicle was taken to an independent mechanic and the repair was pending. The manufacturer was made aware of the failure. The failure mileage was approximately 25,000.

Apr 07, 2025

The contact owns a 2018 Ford Expedition. The contact stated that while starting the vehicle, there was a loud clanking sound coming from the engine compartment. The check engine warning light was illuminated. The contact stated that while driving at an undisclosed speed, the failure recurred with the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that the cam phasers had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 130,000.

Mar 25, 2025

The contact owns a 2018 Ford Expedition. The contact stated while driving at an undisclosed speed, the vehicle shuddered abnormally with the check engine warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the engine needed to be replaced. The vehicle was then taken to a dealer where it was diagnosed and determined that all 4 VTC cam phasers needed to be replaced. The vehicle was not repaired. The contact related the failure to Customer Satisfaction Program: 21N03 – Supplement #4 which the vehicle had previously been repaired under; however, the cam phasers were not replaced. The contact stated that only a software update was performed. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 141,000.

Aug 09, 2024

VEHICLE SPEED CONTROL

4 complaints

I am experiencing delays in transmission shifting when the vehicle is cold. This behavior has recently started at about 85k miles. I have taken to dealer and had the transmission oil changed and Ford recommended cleaning the solenoids (at my cost). The dealer also resets the controller to relearn as well. I experienced the issues while driving away after the work, but I have been asked to drive around for a week and see is the problem 'goes away'. We'll see.

Jan 21, 2024

The contact owns a 2018 Ford Expedition. The contact stated while driving 65 MPH and attempting to change lanes, he depressed the accelerator to overtake the other vehicles and the accelerator became stuck. The contact stated that the cruise control had been activated while attempting to make the lane change. The contact stated that he removed his foot from the accelerator pedal however, the vehicle remained accelerating to almost 100 MPH. The contact tapped the accelerator pedal to release the stuck pedal however, the accelerator pedal failed to respond. The contact placed his foot underneath the pedal and physically released the pedal. The contact stated that the accelerator pedal responded and the vehicle slowed. The contact stated that the check engine warning light was illuminated. The contact stated he checked the vehicle service app on his phone and stated that the app showed two catalytic converter warnings had been displayed. The contact had taken the vehicle to a local dealer where it was not yet diagnosed or repaired. The manufacturer had been informed of the failure. The failure mileage was 65,647.

Sep 12, 2022

SPEEDOMETER IS READING INCORRECTLY, DOES NOT MATCH GPS REPORTED SPEED OR THE PLAY PLACE OFFICERS SPEED WHEN HE CLOCKED ME GOING 13 MILES AN HOUR OVER THE SPEED MY ADAPTIVE CRUISE WAS SET AT. CRUISE CONTROL WAS SET AT 76 MILES AN HOUR AND MY PHONE WAS NOT ON THE GAS, THE GPS ON MY MAP APPLICATION SHOWED I WAS GOING 87 MILES AN HOUR AND THAT IS THE SPEED THE POLICE OFFICER NOTED AS WELL.

Jun 22, 2019

RECENTLY I RENTED A FORD EXPEDITION. MUCH OF THE DRIVING WAS IN AN AROUND THE MOUNTAINS SURROUNDING YELLOWSTONE NATIONAL PARK. WHILE I FOUND THE VEHICLE EASY TO DRIVE THERE IS ONE GLARING SAFETY ISSUE CONCERNING THE ABILITY TO DOWNSHIFT. ONE MUST TAKE THEIR EYES OFF THE ROAD TO LOCATE THE + OR - BUTTONS ON THE CENTER CONSOLE TO CHANGE GEARS. THESE BUTTONS SHOULD BE LOCATED ON THE STEERING WHEEL. NOT ON THE CENTER CONSOLE.

Aug 05, 2018

ELECTRICAL SYSTEM

4 complaints

The screen does not turn on making the backup camera not work.

Aug 21, 2023

Electrical fire under hood occurred spontaneously. Just before my vehicle shut off the dash board read something about to conserve battery shut engine off. Pulled over got out of car and it burned . Insurance agent is investigating. Sherriff and fireman said it was electrical fire under hood. Had I not decided to pull over at rest stop when I did we would have been on freeway when it ignited.

Jul 19, 2021

Fire: 1

THE VEHICLE FAILED TO START 3 DIFFERENT TIMES. THE FIRST TIME WAS IMMEDIATELY AFTER PURCHASE OF THE VEHICLE - IT STARTED AFTER 30 MIN AND WAS TAKEN BACK TO THE DEALERSHIP. THEY REPLACED THE BATTERY AND NO ISSUES UNTIL 4 DAYS THEN IT OCCURRED AGAIN. THE VEHICLE WAS STOPPED AND PARKED OVERNIGHT AND WOULDN'T START THE NEXT MORNING. THE BATTERY HAD ENOUGH POWER - JUMP STARTING DIDN'T HELP. THE 3 TOW TRUCK WAS FINALLY CALLED INTO TOW THE VEHICLE TO THE FORD DEALERSHIP. THEY REPLACED THE IGNITION SWITCH AND THEN TOOK THE VEHICLE BACK UP TO THE PURCHASING DEALERSHIP. THEY DID A FULL REVIEW OF THE VEHICLE AND DIDN'T FIND ANY FURTHER PROBLEMS. THEN 4 WEEKS LATER IT HAPPENED AGAIN WHERE THE VEHICLE WOULD NOT START FOLLOWING SITTING FOR A COUPLE OF HOURS. AGAIN IT TOOK 4 TOW TRUCKS TO COME TO GET THE VEHICLE TO THE FORD DEALERSHIP. THE PROBLEM WAS THE VEHICLE WOULDN'T STAY IN NEUTRAL TO BE TOWED IT WOULD ALWAYS RETURN TO PARK. THE DEARSHIP THEN REPLACED THE STARTED AND SAID IT WAS THEN TAKEN CARE OF AND WON'T HAPPEN AGAIN. THE EVENTS WERE SEPT 4TH - PURCHASE VEHICLE - 1ST EPISODE, SEPT 8TH - 2ND EPISODE, NOVEMBER 19TH - 3RD EPISODE

Feb 18, 2019

I BOUGHT THIS NEW EXPEDITION JUNE OF 2018. IT HAS PUT ITSELF INTO DEEP SLEEP MODE 8 TIMES. 06/11/18, 08/09/18, 08/19/18, 08/22/18 TWICE!, 10/13/18, 11/11/18, 02/06/19. EACH TIME IT HAD TO BE JUMPED WITH ANOTHER LARGE VEHICLE TO START IT UP. THE FIRST TIME WAS JUNE 11TH JUST DAYS AFTER I BOUGHT IT. WE TOOK IT IN AND THEY SAID NOTHING WAS WRONG. IT HAS BEEN IN THE SHOP 3 MORE TIMES SINCE THEN AND THEY "CAN'T FIND ANYTHING WRONG" THEY ARE NOW SAYING THEY WILL REPLACE THE BATTERY BUT I FEEL ITS SOMETHING WITH ALL THE NEW TECHNOLOGY IN THE CAR AND IT WILL STRAND ME AGAIN. I HAVE LUPUS AND IT HAS STRANDED ME IN 105 DEGREES AND FORD ROADSIDE ASSISTANCE SAID THE COULDN'T COME FOR 1 HOUR AND 45 MINUTES. I HAD TO HAVE A STRANGER TRY TO JUMP IT WITH A SMALL CAR AND IT WOULDN'T CHARGE, THEN A TUNDRA THAT THE MARINA MANAGER DROVE PULLED UP AND HE FINALLY GOT MY CAR GOING....I CAN;T DRIVE A CAR THAT HAS DONE THIS SO MANY TIMES AND THE FORD CORPORATION SAID IT DOESN'T QUALIFY FOR A REPLACEMENT. THEY WANT ME TO DRIVE AROUND WITH CABLES IN MY NEW $83K CAR AND DEPEND ON OTHERS TO HELP ME WHEN I AM STRANDED!! I AM DEALING WITH SERVICE DEPARTMENT OF AUTOMAX FORD IN KILLEEN TEXAS. THEY HAVE BEEN KIND BUT UNABLE TO HELP ME. THIS LAST OCCURRENCE WAS FEB. 6, 2019

Feb 09, 2019

SERVICE BRAKES

4 complaints

During a recent oil change at 14299 miles (04/28/2022), I was told that the rear brake pads were dangerously low and had to be replaced immediately. I previously had an oil change and inspection by the same dealership on 11/17/2021 (10986 miles) and 6/22/2021 at 8685 miles and the brakes were checked ok with no mention of any wear whatsoever. When I asked the service manager what could have caused such a rapid deterioration of the brake pads, I was given a shoulder shake and was told that they didn’t find a problem like calipers sticking and things just happen. This car new with only a couple hundred miles on it when we bought it from the same dealer. My concern is that, at this low mileage, I could have gone longer before I brought it in for an oil change and inspection and, if the pads were that bad, we could have been in a very serious accident. The dealership non-concern about the seriousness of the defect/problem is very concerning. The service facility was QuickLane at Jones Ford, 5757 Rivers Avenue, North Charleston, SC. THE CONSUMER BELIEVED THE USE OF THE CRUISE CONTROL WAS THE CAUSE OF THE BRAKE PADS' RAPID DETERIORATION.

May 04, 2022

TL* THE CONTACT LEASED A 2018 FORD EXPEDITION. THE CONTACT STATED THAT WHILE HIS SPOUSE WAS DRIVING THE VEHICLE AT 10-15 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT FAILED TO STOP. THE VEHICLE CRASHED INTO THE REAR OF ANOTHER VEHICLE. THERE WERE NO INJURIES SUSTAINED BY EITHER DRIVERS. A POLICE REPORT WAS FILED. THE VEHICLE WAS DRIVEN FROM THE SCENE TO THE RESIDENCE. THE CONTACT STATED THAT THE ABS WARNING LIGHT WAS ILLUMINATED. THE CONTACT STATED THAT WHILE DRIVING THE VEHICLE TO THE RESIDENCE, THE BRAKE PEDAL WAS DEPRESSED SEVERAL TIMES AND WENT TO THE FLOORBOARD. THE VEHICLE WAS TAKEN TO BILL BROWN FORD LOCATED AT 32222 PLYMOUTH RD, LIVONIA, MI 48150, (734) 399-4244, BUT WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED IN THE FOUR MONTHS SINCE THE CRASH, THE VEHICLE HAD REMAINED AT THE DEALER DUE TO THE ABS MODULE AND SOFTWARE NOT BEING AVAILABLE TO HAVE THE VEHICLE REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. CASE NUMBER: 21685353. THE APPROXIMATE FAILURE MILEAGE WAS 10,000.

Jun 11, 2019

Crash: 1

TODAY I EXPERIENCED A COMPLETE FAILURE OF THE BRAKES ON MY 2018 FORD EXPEDITION EL. THE BRAKE PEDAL WOULD NOT BUILD ANY PRESSURE WHICH ALMOST CAUSED AN ACCIDENT WITH MY CHILDREN IN THE VEHICLE. TO ANSWER THE SPECIFICS REQUESTED BY NHTSA, THE VEHICLE WAS BEING DRIVEN AT 45MPH OR LESS ON A CITY STREET AND THE PROBLEM STILL PERSISTED WHEN THE VEHICLE WAS STOPPED. THE ONLY WAY TO BUILD BRAKE PRESSURE WAS TO TURN THE VEHICLE OFF AND PUMP THE PEDAL. THIS VEHICLE IS LESS THAN 6 MONTHS OLD AND FOR HOW MUCH FORD CHARGES FOR A LIMITED EDITION EXPEDITION YOU EXPECT TO NOT HAVE YOUR BRAKES FAIL. THIS IS UNACCEPTABLE, FORD! THANK GOD NOBODY WAS KILLED BY THIS MANUFACTURING FLAW.

Oct 02, 2018

PURCHASED NEW 2018 EXPEDITION FX4 XLT WOTH CLASS IV TOWING PACKAGE AND OTHER OPTIONS RELYING ON FORD, ITS DEALERS, AND FORD'S PR, THAT VEHICLE COULD TOW TRAILERS UP TO CERTAIN WEIGHT. BUT, ONCE WENT TO PURCHASE TRAVEL TRAILER TO TOW, DISCOVER THAT FINE PRINT HARD TO FIND FORD DISCLOSURE HAD FAR LOWER TOWING LIMITS UNLESS PURCHASE ADDITIONAL EXPENSIVE TOWING OPTIONS. ALSO, VEHICLE LACKS TRAILER BRAKE CONTROLLER THAT IS REQUIRED IN MANY PLACES BY LAW AND NECESSARY TO TOW ALMOST ANYTHING SAFELY. IT IS POSSIBLE THAT BUYERS WILL NOT KNOW THE FOREGOING AND TOW RESULTING IN DANGEROUS RISKS AND POTENTIAL THIRD PERSON INJURIES/DEATHS IN CRASHES INVOLVING THE TOWING OF HEAVY TRAILERS WITH NO BRAKE CONTROLLERS.

Aug 10, 2018

VISIBILITY

3 complaints

The contact owns a 2018 Ford Expedition. The contact stated that the sunroof made a grinding sound while retracting and failed to close properly. Additionally, the slide cover was unable to close as designed. The vehicle was not taken to the dealer to be diagnosed or repaired. The contact believed that the failure was related to the sunroof motor or the gears, or both. The manufacturer was informed of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was unknown.

Jul 24, 2025

The contact owns a 2018 Ford Expedition. The contact stated that while driving at an undisclosed speed and attempting to stop the vehicle, water started to enter through the instrument panel. No warning lights were illuminated. The vehicle was taken to the dealer where it was diagnosed that the tracks on the moon roof had failed and needed to be replaced; however, the moon roof was re-sealed as a temporary fix. The vehicle was repaired. The contact was concerned that the failure would reoccur. The manufacturer was notified of the failure and the contact was informed that half the cos would be covered. The failure mileage was approximately 51,271.

Apr 10, 2023

Panoramic sunroof stuck in open position. Will not close without multiple failed attempts. When closing the sunroof makes a cracking and grinding noise. This issue has been identified by Ford, however my VIN does not currently fall under the open recall. Therefore, Ford will not cover the repair. Details of existing recall are below… Ford TSB 18-2374 Some 2015-2019 F-150, 2017-2019 F-Super Duty, 2018-2019 Expedition/Navigator vehicles equipped with a vista roof opening panel may exhibit a binding/sticking, glass stuck open or closed, noisy operation including chatter, rattling, or grinding. This may be due to the glass brackets cracking and/or breaking apart. The glass panel brackets are serviceable separately from the frame assembly and require the roof opening panel glass to be moved to the vent position. Follow the Service Procedure steps to correct the condition.

Jan 11, 2023

ELECTRICAL SYSTEM,ENGINE

3 complaints

There was a recall for cam phasers etc under 21N03. My car was fixed in 2021 but the parts they put it in were not the updated parts. I was told it was the same recalled parts that they used to replace. Now I am having the same issue again . I am not currently driving my vehicle until it can be remedied. I contacted the dealership and they are not willing to cooperate or work with me. I will attach the report that was done back in 2021 below.

Jul 15, 2025

Front Blower motor not working correctly. Engine Valve cover driver side small crack.

May 16, 2023

The contact owns a 2018 Ford Expedition. The contact stated while starting the vehicle, he heard a loud noise coming from the vehicle. The vehicle was taken to the dealer and the contact was informed that the cam phaser needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and informed of the failure however, no assistance was provided. The failure mileage was 83,000.

Sep 27, 2022

POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE

3 complaints

Since purchasing the vehicle we have had extensive issues with the driveability of the car. Leading up to the eventual full transmission replacement, we surfaced the issues below repeatedly for over a year and a half. Yet, we were always told "everything is fine" "we couldn't duplicate what you are describing" or "the vehicle has to learn how you drive". Biggest Issues: - Poor shifting of gears with sudden jerking and/or random accelerations - Vehicle not accelerating - acts stuck - Loss of 'power' vehicle does nothing - Eventually complete transmission failure in the middle of an intersection The transmission was completely replaced in Fall of 2023. Mind you this was only after I elevated my concerns to Ford Corporate who sent a specialist to investigate. Only then did Koons Ford acknowledge that yes there is a "big problem". Yet, since the repair the jerking and power issues have continued. When we followed up immediately after the repair we were told again "vehicle has to learn how you drive". So I waited 3000 miles and reached out again and was told I needed to go to the dealership and drive it with a technician in the car (yet again, not taking my word seriously). Then this summer the issues intensified and eventually the power boosters failed and needed to be replaced. This vehicle is NOT safe and Ford has misled me along the way. It has been a constant fight to get them to help us. Bottom line, this is our primary family vehicle as we have five children, four of whom I drive around daily. It is not safe or reliable. The vehicle has almost led to three major accidents, where I was stuck with cars honking at me. It's pretty pathetic when friends and coworkers frequently say "you don't have your car again?!? What's wrong with it now?" Please I kindly ask that you hold Ford fully accountable. I am now aware that when I inquired about a buy back in 2022, I should have not been told "no you are not eligible".

Oct 14, 2024

My 2018 expedition has been repaired by Ford dealership three times. The vehicle started with a hesitancy to shift into reverse then eventually a hard jerk into gear. following that, it began to hesitate to accelerate and rattle and shake hard enough to shake the steering wheel. The powertrain loss warning came on ford pass. Ford dealership said it was transmission and rebuilt it. Three weeks following the repair the very same shaking, rattling and crunching sound started again with power loss. It was intermittent and dealership said with no codes they couldn’t recreate the issue and so no help. The following day on the highway, it started again. I was attempting to stop at a red light and with my foot on the brake, the vehicle attempted to lurch forward and try to go despite the brake. Thankfully, the light turned green and the car in front of me moved. As I continued to drive, I was left stranded with the codes showing actuator failure and cam shaft failure. The dealership then said it was the cam shaft and all actuators that needed to be replaced this time. The SAME rattling and shaking and power loss they said was caused by the transmission they rebuilt 3 weeks earlier but now it is caused by the cam shaft. So 2 repairs later and 4 weeks, it did it again and this time it caught on fire and burned a hole in my hood. The dealership called me the day after I had it towed into the dealership smoking staying it was the heater hoses that caused the shaking, rattling and power loss. Said they could have it fixed the next day. It is a disaster. It is a major safety issue and I am still paying payments on this car that ford cannot fix. This car needs to be recalled and they need to refund for cost of vehicle. This car is going to kill someone!

Jul 02, 2024

Driving thru Atlanta traffic stop and go . One time I took off and all of a sudden vehicle jerk and didn’t go . NExt time it lunged forward . I notice the vehicle shutters between 20-30mph Tried to get a appointment with ford nothing available till august . Went to Panama City shopping the other day with my son he could not believe how bad the vehicle lunges sometimes and sometimes it stalls before take off . Makes me very nervous to drive am I gonna get stranded in heavy traffic ? Call ford they said needs PCM reprogrammed she tried to make appt to no avail . She knew what I was talking bout when I called her .said you need to get it in right of way .Well dealerships say they are months out what do I do now . Ford is a disgrace 80,000 for vehicle and I have had numerous issues

Jun 29, 2022

POWER TRAIN,ELECTRICAL SYSTEM

3 complaints

I've had a couple of issues with my expedition since day 1. When I click on my memory seat to adjust seat/mirror etc. the front mirrors (not the encasement) will turn in one direction and sit there and click until I manually adjust the mirror(s). Today is 10/24/23 and starting yesterday, I was in rush hour traffic and noticed my motor sounded different. Then while headed to work it just started jumping and popping in and out of gear. I am in stopped traffic at one minute and the next be going 70 mph then back to stuck in traffic. So, my fear is driving this thing and it totally failing and it causing a serious wreck to myself and others! This needs to be addressed or I will never own another Ford.

Oct 24, 2023

We were having issues with our transmission shifting very abruptly and making a clunking noise back in late June 2023. This was occurring as my wife was traveling out of state for a funeral to Michigan. We were able to drop the vehicle off at a certified mechanic in Ohio, and were told that they were metal shavings inside the transmission. The vehicle sat there for several weeks, waiting on a new/remanned transmission from a local Ford dealership. The transmission was replaced, and I flew back to Ohio to drive the vehicle back to Virginia in early August. At first, the vehicle was shifting and driving normally as it should. However, when I was near Richmond, Virginia, I had to change lanes to pass a semi, and when I pressed the gas, all power was lost and the lights on the dash went completely black. About 2 to 3 seconds later, the vehicle shifted with a loud clunk and the advance track warning light came on. The malfunction nearly caused an accident as vehicles behind me had to slam on their brakes, as I finally made my way to the shoulder of the road to collect myself.

Aug 19, 2023

UPON STARTUP, THE DASHBOARD MONITOR WILL NOT LIGHT UP AND THE TRANSMISSION WILL NOT GO INTO GEAR. THIS INCLUDES NO BACKUP CAMERAS, RADIO, MAPPING FEATURE, OR HANDS FREE BLUETOOTH ON THE MONITOR, WHILE THE DASHBOARD (DIRECTLY IN FRONT OF THE STEERING WHEEL AREA) FLASHES ON/OFF THAT "TRANSMISSION NOT IN PARK", OR "OIL NEEDS TO BE CHANGED", YET THE TRANSMISSION IS STUCK IN PARK. AFTER TRYING SEVERAL TIMES TO MANUALLY PUT THE CAR INTO "DRIVE" IT WILL FINALLY START MOVING FORWARD WITH A GRINDING SOUND, BEFORE COMING TO AN ABRUPT STOP. THIS SEQUENCE OCCURS SEVERAL TIMES, UNTIL I TURN THE CAR OFF AND TRY AGAIN. IT SOMETIMES TAKES 4-5 ATTEMPTS OVER 5-10 MINUTES TO GET THE CAR MOVING WITH ALL ITEMS WORKING PROPERLY. IT SEEMS ELECTRICAL, SINCE IT ALWAYS INVOLVES BOTH THE DASH MONITOR AND THE TRANSMISSION AT THE SAME TIME.

Apr 23, 2020

VISIBILITY/WIPER

3 complaints

TL* THE CONTACT OWNS A 2018 FORD EXPEDITION. THE CONTACT STATED THAT THE WINDSHIELD WIPERS FAILED TO TURN OFF. THE CONTACT STATED THAT THE FAILURE STARTED INTERMITTENTLY AND WORSENED. THE CONTACT CALLED DICK SMITH FORD OF COLUMBIA (7201 GARNERS FERRY RD, COLUMBIA, SC 29209, (803) 254-4000) AND SCHEDULED AN APPOINTMENT. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND PROVIDED CASE NUMBER: CAS25128240. THE FAILURE MILEAGE WAS APPROXIMATELY 54,736.

Dec 11, 2019

THE SIDE-VIEW MIRRORS ON THE 2018 FORD EXPEDITION PLATINUM ARE DEFECTIVE. WHEN ADJUSTING THE MIRROR TO A PRE-PROGRAMMED NUMBER, THE MIRRORS WILL START TO ADJUST THEMSELVES AND UNFORTUNATELY WILL GET STUCK IN AN ENDLESS LOOP OF MOVING, CLICKING, MOVING, CLICKING, ETC... THE MIRROR FAILS TO ADJUST TO THE PROPER LOCATION AND THE MIRROR MOTOR CAN'T BE STOPPED UNTIL THE KEY IS REMOVED FROM THE IGNITION AND THE ELECTRICAL SYSTEM IS COMPLETELY SHUT OFF (I.E. OPENING AND CLOSING THE DRIVER-SIDE DOOR. I'M SURE IF THE MOTOR ON THE MIRROR WAS ALLOWED TO CONTINUE TO ADJUST ITSELF IN AN ENDLESS LOOP, IT COULD POSE A FIRE HAZARD (NOT TO MENTION THE FUNCTION ITSELF IS FAULTY). THIS ISSUE APPEARS TO BE SOMETHING MANY OTHERS ON FORUMS ARE STARTING TO COMPLAIN ABOUT. FORD IS AWARE OF THE ISSUE AND HAS NOT OFFERED TO RESOLVE IT FOR ANY OF ITS CUSTOMERS. THIS ISSUE CAN OCCUR WHILE THE VEHICLE IS MOVING OR STATIONARY.

Oct 30, 2019

TL* THE CONTACT OWNS A 2018 FORD EXPEDITION. WHILE DRIVING 40 MPH, THE AIR CONDITIONING VENTS WERE NOT FUNCTIONING. THE VEHICLE WAS TAKEN TO O. C. WELCH FORD LINCOLN (LOCATED AT 4920 INDEPENDENCE BLVD, HARDEEVILLE, SC 29927, (843) 288-0100) WHERE IT WAS DIAGNOSED THAT THE FRONT AND REAR EVAPORATORS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 36,730. *AS

Sep 19, 2019

ENGINE AND ENGINE COOLING,POWER TRAIN

2 complaints

The contact owns a 2018 Ford Expedition. The contact stated while driving approximately 70 MPH, the vehicle lost motive power and failed to accelerate as intended. The contact stated that the power train warning light was illuminated. The contact pulled over to the side of the road and restarted the vehicle. The vehicle was then taken to a dealer to be diagnosed and the contact was informed that the catalytic converter and transmission needed to be replaced. The vehicle was not repaired. The vehicle was taken to an independent mechanic and was repaired; however, the failure reoccurred several months later. The manufacturer was notified of the failure. The failure mileage was 156,000.

Jul 09, 2025

The contact owns a 2018 Ford Expedition. The contact stated that while operating the vehicle, there was a coolant leak underneath the vehicle. The vehicle was taken to the local dealer who diagnosed that the coolant hoses were faulty and needed to be replaced. Additional, while driving at various highway speeds the vehicle lost motive power and would not properly accelerate. The cause of the failure was not yet determined. The local dealer was notified of the failure, but no assistance was offered. The manufacturer was not yet contacted. The failure mileage was 80,000.

Aug 29, 2024

ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

2 complaints

Our 2018 Ford Expedition Max caught fire while on a test drive after repairs at Canby Ford. It completely caught fire and is a total loss. We were supposed to pick up the car an hour later. If our kids were in the car strapped into car seats, there may not have been enough time to get them out. They could have died. The mechanic who was driving saw the engine smoking and jumped out (he was at risk). The whole car was gone within 2-3 minutes. In my opinion it exploded as all the windows were blown out. The motor block melted, and the front end of the car is gone. There is a report with Canby Oregon Fire Department. Most people would assume it was overheating, get out and open the hood with their family still in the car. If that had happened people could have died. There were no check engine lights on when we took it to Ford. It was just close to the end of a warranty and there was an engine rattle we wanted fixed. Please come look at the car to investigate. It is at an independent insurance valuation company. I asked the manager of Canby Ford if he would report it to Ford Motor Company, he said no it would just go through their insurance. Ford needs to recall all of the expeditions so someone doesn't die in a fire. Ford already settled on the 2021 Ford Expedition and there are fires on older models and similar F150 Trucks. There are many reported fires without a recall. Please recall all the expeditions and investigate all the other Ford Vehicle fires swept under the rug. We don't want someone else to die due to a lack of action. The previous Ford Expedition settlement is not enough as it only covers 2021. If nothing is done, we plan to go public on the news with the photos, hopefully we can say NHTSA did something (or we can say NHTSA did nothing). Other families are at risk, they need to know to get out fast cause it could catch fire or explode. They need to not assume the engine is overheating (as I would have done 2 months ago) it could be on fire .

Oct 09, 2023

Fire: 1

About 20 times now, while I am on the freeway, sometimes when I am coasting, and other times when I am trying to quickly accelerate, my car down shifts out of nowhere and loses power, again either when I am in the fast lane coasting, or trying to merge into traffic. It's like it is going to stall and when I step on the gas, it just revs and doesn't get into gear and go. I have almost been rear ended because I go from 70 to like 40 mph. When I was trying to merge into traffic, I got partially into the other lane and then it just wouldn't go. I could easily have been hit. One time when I was coasting and it did it, a warning came on, and then a check manual, but it went away too fast. I have taken it to the dealer and a repair shop multiple times and they can't replicate it. It could definitely cause an accident as my car suddenly slows down and it won't accelerate. I have to wait about 10-15 seconds until it reengages. It makes aloud clunking/dropping sound as if I ran over something and one time it sounded like a million pebbles were inside my engine and under my car. No diagnostic numbers are coming up and it's like no one knows what I am talking about. But multiple Fords are having this issue and they are not doing anything about it. I took it in during my warranty and now it's out of warranty and I'm going to have to pay for something that they should have repaired from the get go. This is dangerous.

Sep 09, 2022

ENGINE,FUEL/PROPULSION SYSTEM

2 complaints

There is a recall on many 2018 CAM Phasers. My vehicle has the same issue with the recalls on many 2018 Expeditions that also effect the EPA ratings. For some reason FORD says the Recall is not my vehicle but they knew their was an issue and the FORD dealership tried to do a software update but the issue was never cured. They never performed the needed next step remediation. The ongoing CAM phase issue cause engine light to stay on. This has been going on with them for several years. They never would do the part 2 cure.

Jul 03, 2023

I own a 2018 Ford Expedition 3.5L ecoboost. This is an engine and vehicle that is known to be problematic. In 2020 I took my vehicle to the dealership to have the noisy cam phasers fixed, a TSB was found and the parts HL3Z cam phasers were replaced under the powertrain warranty. Now in September of 2022 my vehicle started having issues again with the same problem, since Ford told me that the problem was only noisy and not a mechanical issue I delayed taking it to the dealership until it started having more issues with idle, power, etc. It is then that I find out there was actually an extended warranty/ recall for that issue. Ford is denying my claims saying that my problem was fixed in 2020. The parts it was fixed with are faulty, and redesigned parts were released in late 2020 that have a stiffer spring that allows the oil pressure to hold better than the HL3Z cam phasers, thus preventing the problem. The new parts the ML3C cam phasers are now what Ford is telling me need to be replaced at a $3000 charge, in addition to the timing chain which has been damaged due to the cam phaser issue. Ford needs a recall on vehicles with the faulty HL3Z 6C525 cams not just a vin recall. This is a KNOWN problem for this engine and Ford is doing everything they can to avoid paying for their mistake.

Mar 24, 2023

FUEL/PROPULSION SYSTEM

2 complaints

Car doesn’t let me pump fuel at gas station and overfills even when the tank is empty. Gas leaks from the bottom of the car. Weird suction noise comes from the fuel filler neck. I was doing research and found that many people have this same problem with my car and there’s a recall for this but for the 2015-2016 models and not the 2017. It’s a recall on the evap system suction pump and code is 20Y6.

Jun 29, 2022

The Fuel filler assembly on our 2018 Ford Expedition broke while filling the vehicle with fuel, causing the entire fuel filler assembly to pop out of the side of the vehicle. The parts appear to be made of weak plastic and/or may be caused by poor design execution. The concern is that this defect could cause fuel to leak out of the assembly and/or the broken parts may render the vehicle unable to be filled with fuel and leave the driver stranded. The vehicle was taken to the dealer who confirmed the issue and ordered replacement parts.

Jun 30, 2021

EXTERIOR LIGHTING,UNKNOWN OR OTHER

1 complaint

Just purchased a certified used vehicle. 1) passenger DTRL is half way burnt out. Upon reading tons of forums online, I’m seeing this is a VERY COMMON issue. 2) the back up guide lines on the back up camera does not show. After master reset of the sync system , the lines appeared once. Since then it has not shown ever again.

Jul 11, 2025

POWER TRAIN,VEHICLE SPEED CONTROL,UNKNOWN OR OTHER

1 complaint

Component/System That Failed: The 10R80 automatic transmission is malfunctioning. It causes harsh shifting, delayed acceleration, hesitation, and unpredictable surging. These issues have been confirmed as part of Ford’s internal TSB 23-2250, which directly references this transmission defect. The vehicle is available for inspection upon request. Safety Risk: This transmission failure poses a serious safety risk. The hesitation and delay in acceleration occur during merging, turning, and highway driving, which can cause near misses and sudden loss of power. The delayed response time compromises my ability to move safely through traffic. Reproduced/Confirmed: Yes. The issue was confirmed by Liberty Ford in Fayetteville, NC, after I paid for a diagnostic. The service department acknowledged the symptoms but refused to cover the diagnosis or repair under warranty since no recall was showing under my VIN. Inspected by Others: The vehicle has not been inspected by the manufacturer directly or by law enforcement or insurance. However, it was diagnosed and documented by an authorized Ford dealership (Liberty Ford in Fayetteville NC). Warning Lamps or Symptoms: There were no warning lamps or error codes. The symptoms began subtly but became consistent over time. The first noticeable event was approximately in “early 2025”, with increased severity since then. I submitted a written complaint to Ford on June 9, 2025, via USPS Priority Mail (Tracking #[XXX]) and also filed a certified safety complaint with NHTSA (Tracking #[XXX]) but have received no response. I am requesting formal investigation and recall action. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Jul 07, 2025

SUSPENSION,ENGINE

1 complaint

With only 53500 miles the gears stopped working. The gear shift pulls and hesitates when changing gears. The engine pulls when excelerating even at low speeds while struggling to shift. The Cam is also causing issues with loud start up sounds.

Jun 12, 2025

POWER TRAIN,UNKNOWN OR OTHER

1 complaint

I have had several issues with this vehicle throughout the years I have owned it. The current issues I am writing about include: transmission failure and replacement, rear passenger door no longer opening and continued issues with the Catalytic convertors. When it comes to the transmission it was unsafe to drive as the gears continued to slip while driving and cause the vehicle to temporarily loose power. This could have resulted in an accident. The vehicle is currently having the transmission replaced at a repair shop where they confirmed the issues. They will also be looking at the other two issues as well. The door not opening poses a huge safety concern as we are only able to use one rear door for entering and exiting.

May 23, 2025

POWER TRAIN,SEAT BELTS,ENGINE

1 complaint

Cam phaser and timing chain assembly is beginning to fail. Ford has a CSB out on this problem but is unwilling to repair or replace components. Transmission has had to be replaced be cause of failure at 100000 miles. I’ve had to replace the water pump twice on my Expedition. Driver side seat belt no longer retracts.

Apr 20, 2025

AIR BAGS,SEAT BELTS

1 complaint

Driver side seat belt air bag popped while driving down the road and now the seat belt will not retract. shows that this is a known issue in my year model but this is not a recall for my specific vin.

Apr 09, 2025

POWER TRAIN,ELECTRICAL SYSTEM,UNKNOWN OR OTHER

1 complaint

What component or system failed or malfunctioned TRANSMISSION, and is it available for inspection upon request YES How was your safety or the safety of others put at risk? I WAS DRIVING ON A MAJOR 8 LANE HIGHWAY AND COULD NOT EXCELERATE SAFTLY TO GET OUT OF THE WAY OF TRAFFIC Has the problem been reproduced or confirmed by a dealer or independent service center? YES Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? YES, MANUFACTURER FORD & AAMCO TRANSMISSION Were there any warning lamps, messages or other symptoms of the problem prior to the failure, NO and when did they first appear THE CHECK ENGINE LIGHT CAME ON RIGHT AFTER THE TRANSMISSION STOPPED WORKING PROPERLY. FIRST THE TRANSMISSION WOULD NOT EXCELERATE AND THEM THE CHECK ENGINE LIGHT CAME ON THIS TRANSMISSION HAS FAILED 3 TIMES KEEPS LEAVING ME STRANDED ON THE SIDE OF THE HIGHWAY. EVEN AFTER REPAIRS HAVE BEEN DONE WITH AAMCO PLEASE HELP ME I AM SCARED TO DRIVE MY TRUCK TRANSMISSION KEEPS FAILING

Mar 01, 2025

POWER TRAIN,VEHICLE SPEED CONTROL

1 complaint

“Shift system fault” flashes on dash and car suddenly and violently shakes and loses power at higher speeds when trying to accelerate. Also heard a metallic grinding/metallic rattle noise under the car and could not accelerate. Has happened multiple times over the last year and a half.

Apr 15, 2024

WHEELS,SERVICE BRAKES

1 complaint

While parked on an incline, the truck's wheels disengaged and it rolled down backwards. The emergency brake was set. The vehicle has a known defect but the dealership will not expedite the repair.

Jan 24, 2024

FUEL SYSTEM, GASOLINE,POWER TRAIN,ENGINE

1 complaint

The contact owns a 2018 Ford Expedition. The contact stated that while driving 45 MPH, the vehicle lost motive power inadvertently. The contact was able to pull to the side of the road. The contact was able to restart the vehicle after several attempts; however, the vehicle sputtered while restarting. The contact was able to continue driving. The contact stated that the failure had been recurring while driving. The check engine warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed that the fuel pump needed to be replaced. The contact related the failure to NHTSA Campaign Number: 18V392000 (Fuel System, Gasoline); however, the VIN was not included. Additionally, the dealer informed the contact that oil was leaking from the timing valve cover and the front struts. The dealer also informed the contact that the transmission lines were leaking. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 64,500.

Jan 17, 2024

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE

1 complaint

When car is stopped, the engine dies and it reads on screen “ place car in park to restart engine”. This is not the automatic stop/start. Car has died a handful of times when in stopped traffic or at red lights. Sometimes taking several seconds to get engine running again. Brand new battery. Herb Chambers Ford dealership used diagnostics on 9/29/23 and “did not find anything broken”.

Oct 02, 2023

VEHICLE SPEED CONTROL,ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

My vehicle has been making a very loud rattling sound upon starting. I reached out to the Ford service department about this and they said the cam phaser is failing but the customer satisfaction program has expired and they will no longer cover it. I never received a letter from Ford regarding this customer satisfaction program (I hadn't moved since buying the car, so it wasn't an address problem); they blamed the DMV and said they are the ones that mail out the letters and don't know why I didn't receive it. They quoted me $3,300 to fix it. I obviously can't afford that so I took my vehicle back and continued to drive it. Today the check engine light came on and I noticed my vehicle is sluggish to accelerate. Upon researching cam phasers failing I found this: "You could also lose power suddenly while you are driving. This problem puts you at risk of an accident and exposes others on the road to a dangerous situation. ". I believe the cam phaser problems in the 2018-2020 Expeditions should be a recall. It is a safety issue.

Sep 25, 2023

FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM

1 complaint

The contact owns a 2018 Ford Expedition. The contact stated while driving 75 MPH, the vehicle started sputtering and unintendedly decelerated to 20 MPH. The contact was able to continue driving; however, the vehicle failed to exceed 20 MPH. The vehicle was taken to the dealer, where the fuel pump was replaced; however, the failure persisted. The vehicle was taken back to the dealer, where the fuel pump and the Variable Valve Timing (VVT) Solenoid were replaced; however, the failure recurred increasingly, and the vehicle lost motive power on several occasions. The contact veered to the side of the road and restarted the vehicle after several attempts and continued driving. The vehicle was taken to the dealer, where the fuel pump and the fuel pressure rail were replaced; however, the check engine warning light became illuminated. The contact's husband replaced the O2 sensors, the catalytic converter, and the fuel pump stand; however, the failure persisted. The contact stated that the vehicle shuddered while idling in the parking lot and then lost power. The contact was able to restart the vehicle after several attempts; however, the failure recurred while driving to the residence. The vehicle was taken to a second dealer, Tri-State Ford (1900 Interstate 40 Access Rd, Amarillo, TX 79103), where it was diagnosed that a relay in the wiring harness box had failed, and the wiring harness box needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 46,000.

Sep 07, 2023

VISIBILITY,STRUCTURE

1 complaint

The contact owns a 2018 Ford Expedition. The contact stated that he had taken the vehicle to the dealer on four separate occasions due to moisture leaking from the panoramic sunroof. Due to the failure, the roof headliner needed to be replaced a second time. The contact stated that the panoramic sunroof had never been used and had remained covered. The manufacturer had been notified of the failure and referred him to the NHTSA Hotline. The vehicle was not repaired. The failure mileage was approximately 20,000.

Jul 12, 2023

POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

1 complaint

Door locks don’t unlock on 3 out of 4 doors. Transmission jerks and acts like losing power frequently. Engine tries to die at idle when stopping. Timing chains failed along with cam phasers yet symptoms still continue. Heater hoses leak to heater core. This caused high temps of 255 degrees to occur for engine.

Jun 19, 2023

VEHICLE SPEED CONTROL,SERVICE BRAKES,ENGINE

1 complaint

No Brakes, Engine Racing, & ignition would not turn off, yes available for inspection at Seth Whatley Ford. Car crashed which was the only way it came to a stop, wheels were still turning when I got out of the car, if anyone one had been around they would have been hurt or killed. Towed to dealer, dealer was unable to find any evidence on their side. Insurance adjuster came out and assess the damage from crash. There was no warning lights or sensors that were working during this episode. Monday, March 27, 2023 at approximately 10am, I got into my Expedition to start my vehicle, the brake pedal was depressed as I pushed the button to start the car, and the engine was running smoothly. Foot was on the brake pedal when I put the car into reverse, the car shot out from the carport and engine was racing. I tried to pump the breaks and push the engine button, while guiding the car as it kept going faster and faster, until I hit a trailer that was attached to a truck. There was two witness that saw everything, that went on. I feel this car is DANGEROUS. If this had occurred when my family was around serious injuries could have occurred, or if I had been in a parking lot, there was no way to stop and I was not in control. Safety is the first issue. Special Note - I took my car in February 2022 for the recall.

May 15, 2023

Crash: 1

VEHICLE SPEED CONTROL,ENGINE,POWER TRAIN

1 complaint

As the vehicle accelerates it experiences a loss of power randomly at both low speeds and high speeds (like it randomly shifted into neutral) then after letting off the accelerator the vehicles clunks into gear. I experienced this at roughly 60k miles in both 2WD and less frequently in 4WD. It’s absolutely a safety hazard while driving on the roads.

Feb 19, 2023

STRUCTURE,LATCHES/LOCKS/LINKAGES

1 complaint

In below-freezing weather, the driver's side door latch of our 2018 Ford Expedition cannot be operated from the inside or outside of the vehicle, greatly limiting the occupant's ability to enter or exit the vehicle. A Ford technician advised today that the latch would need to be replaced. There were no indicators of a malfunction. Similar year Ford F-150s are covered for this issue by Ford's Customer Satisfaction Program 18N03. https://static.nhtsa.gov/odi/tsbs/2018/MC-10148744-9999.pdf

Feb 08, 2023

POWER TRAIN,SERVICE BRAKES

1 complaint

The contact owns a 2018 Ford Expedition. The contact stated that while in park and releasing the brake pedal, the vehicle rolled forward three to four feet and then stopped. There were no warning lights illuminated. The vehicle was taken to the local dealer, but the mechanic was unable to duplicate the failure. The vehicle was not repaired. The contact called another local dealer, Middleton Ford (7520 Century Ave, Middleton, WI 53562; 608-831-7725) but the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 99,000.

Feb 06, 2023

ELECTRICAL SYSTEM,LATCHES/LOCKS/LINKAGES

1 complaint

The rear doors don’t unlock frequently. They won’t open from inside or outside often and require repeated unlocking of locks. The manual lock pulls on top of panel are too recessed to grab and pull. The drivers door never comes up at all.

Feb 06, 2023

EQUIPMENT

1 complaint

Air conditioning unit has failed and after further investigation there is metal found in compressor which forces a full replacement of the AC unit. After further investigation (online forums and discussion with dealerships) this is not uncommon. The compressors are faulty and for a 5 year old car to find metal and replace air conditioning issues multiple times in past few years.

Jun 30, 2022

LATCHES/LOCKS/LINKAGES

1 complaint

The door opened while driving due to the latch on the rear passenger door popped open. The door now will not stay latched closed. It just continues to stay open. My daughter could have fallen out of the car while we were driving because of this.

Apr 04, 2022

STRUCTURE,LATCHES/LOCKS/LINKAGES,UNKNOWN OR OTHER

1 complaint

Drivers door would not close. Took 10 months for the new door latch to get shipped to my local Ford dealer . They charged us $ 708.00 to do the repair .

Feb 10, 2022

VISIBILITY,EQUIPMENT

1 complaint

The contact owns a 2018 Ford Expedition. The contact stated that the retractable running board failed to open or close intermittently. The contact stated that while stepping on the running board to exit the driver's side door, the running board inadvertently started to close. The contact stated that his foot was caught, and he had to struggle to remove his foot. The contact stated that he sustained no injuries. The vehicle was not taken to an independent mechanic or dealer for diagnosis or repairs. The contact also stated that there were electrical issues with the side view mirrors automatically adjusting without warning. The manufacturer was notified of the mirror failure and advised the contact to call the local dealer. The manufacturer was not made aware of the running board failure. The failure mileage was approximately 50,000.

Aug 30, 2021

ELECTRICAL SYSTEM,EXTERIOR LIGHTING,SERVICE BRAKES

1 complaint

UNDER WARRANTY, MOISTURE WAS PRESENT IN ALL THE REAR BRAKE LIGHTS. THE UPPER (THIRD) BRAKE LIGHT HAD THE MOST CONDENSATION. AN AUTHORIZED FORD DEALER REVIEWED THE ISSUE AND ADVISED FORD DOES NOT COVER MOISTURE WITHIN A LIGHT AS THE MOISTURE WILL DISSIPATE OVER TIME. I ADVISED THE UPPER BRAKE LIGHT WAS NEVER DRY, THEY INSISTED WARRANTY WOULD NOT COVER THE ISSUE. I COULD REPLACE THE LIGHT, I RECEIVED A QUOTE AT THAT TIME. NOW THE UPPER BRAKE LIGHT HAS LESS THAN 2 LED'S WORKING AND THE VISIBILITY IS NEXT TO NOTHING. REVIEWING FORUMS, THIS IS AN ISSUE THAT HAS BEEN PRESENT IN THE FORD EXPEDITIONS SINCE THE NEW VEHICLE DESIGN CHANGE. MY CONCERN IS VERY SIMPLE, THAT BRAKE LIGHT IS IMPORTANT IN THE SAFETY OF OUR PASSENGERS, THOSE AROUND THE VEHICLE AND THE VEHICLE ITSELF. WE HAVE NOT BEEN IN A REAR END COLLISION WITH THIS VEHICLE, BUT IT IS DIFFICULT TO SEE BRAKING OF THIS VEHICLE AHEAD WHEN THE VEHICLE IS ONE CAR AHEAD OF YOU BASED ON WHAT I HAVE SEEN WHEN DRIVING BEHIND THIS VEHICLE MYSELF. I CONSIDER THIS BRAKE LIGHT A SIGNIFICANT COMPONENT OF THE SAFETY FEATURES IN OUR VEHICLE. TIMING OF THE ISSUE WAS OVER A PERIOD OF TIME. FIRST PHASE WAS MOISTURE NOT DISSIPATING, SECOND PHASE HAS BEEN THE LED LIGHTING CONTINUES TO STOP WORKING, A FEW LED'S AT FIRST, NOW ONLY A FEW ARE OPERATIONAL, AND DIM AT BEST DUE TO THE CONTINUED MOISTURE IN THE UPPER REAR BRAKE LIGHT ASSEMBLY.

Mar 05, 2021

POWER TRAIN,EQUIPMENT

1 complaint

WE HAVE A 20018 FORD EXPEDITION PLATINUM, 2WD (REAR WHEEL DRIVE). BOUGHT BRAND NEW. FOR THE PAST MONTH WE'VE BEEN HAVING WHAT SEEMS LIKE TRANSMISSION ISSUES. CAR HAS 45,000 MILES ON IT. A FEW TIMES A DAY THE TRANSMISSION FAILS TO SHIFT AT ALL; ESSENTIALLY GOES IN-BETWEEN GEARS, REVS HIGH, BUT ABSOLUTELY NO MOVEMENT. USUALLY SOON AFTER MOVING FROM A START, SO MAYBE 2ND TO 3RD GEAR OR 3RD TO 4TH GEAR. IT HAPPENS WITHOUT ANY WARNING. HAS NOTHING TO DO WITH THE CARE BEING HOT OR COLD. IT IS VERY SCARY BECAUSE ONE OF THE TIMES, I HAD PULLED OUT FROM A GAS STATION ONTO A HIGHWAY, ACCELERATING NORMALLY TO KEEP UP WITH ONCOMING TRAFFIC WITH I LOST ALL POWER TO THE WHEELS. ENGINE CONTINUED REVVING. THERE WAS NO TIRE SLIPPING - JUST NO MOVEMENT WHATSOEVER. TOOK IT INTO THE FORD DEALER (GOLDEN CIRCLE FORD) IN JACKSON TN WHERE THEY EVALUATED THE VEHICLE AND FOUND NOTHING WRONG WITH IT. THEY APPARENTLY PUT IT ON THE COMPUTER AND DROVE IT; AND WERE UNABLE TO DUPLICATE THE PROBLEM. THEY GAVE ME A RIDICULOUS EXPLANATION THAT THE VEHICLE IS 'LEARNING' (AKA "ADAPTING") TO MY DRIVING STYLE AND THAT IT WAS NORMAL BEHAVIOR. THAT WAS LAST WEEK. SINCE THEN, THE SHIFTING BETWEEN LOW GEARS HAS BECOME SOMEONE ROUGHER/ WITH SOME HESITANCY. I DID RESEARCH THESE VEHICLE AND APPARENTLY THERE MAY BE AN ISSUE WITH THE 10 SPEED AUTOMATIC TRANSMISSIONS NOW BEING USED IN THE F150 TRUCKS WITH MANY PEOPLE DESCRIBING SIMILAR TRANSMISSION PROBLEMS. I JUST WANTED TO LET YOU KNOW THAT THERE IS A POTENTIAL ISSUE, THAT CAN ALSO BE VERY DANGEROUS IF THE CAR STOPS MOVING IN THE MIDDLE OF THE ROAD WITH ONCOMING TRAFFIC. THANK YOU.

Feb 27, 2021

AIR BAGS,SEATS,LANE DEPARTURE

1 complaint

FORD EXPEDITION WAS TRAVELLING AT 50-60KM/HR WHILE PASSING AN EMERGENCY VEHICLE ON A HIGHWAY. THE EXPEDITION WAS STRUCK FROM BEHIND BY A UTILITY VAN TRAVELLING AROUND 110KM/HR. BOTH FRONT SEATS SLID FORWARD AND ALSO RECLINED ON IMPACT. THIS CAUSED BOTH FRONT PASSENGERS TO SUSTAIN BRUISING ON THEIR CALF'S DUE TO THE SEATS SLIDING FORWARD AND WHIPLASH FROM BOTH FRONT SEATS RECLINING. BOTH FRONT SEATS TRAPPED CHILDREN IN THEIR CAR SEATS IN THE 2ND ROW FORM BEING RECLINED. NO AIR BAGS DEPLOYED IN THE ACCIDENT AS WELL!

Dec 01, 2020

Crash: 1

Injuries: 4

AIR BAGS,SERVICE BRAKES

1 complaint

WAS HIT BY A VEHICLE WHILE MAKING A LEFT HAND TURN ON A CITY STREET. TRIED TO STOP THE CAR. BREAKS WOULD NOT WORK AND JUST WENT TO THE FLOOR BOARD. VEHICLE SPED UP. JUMPED 2 CURBS AND HAD TO THROW THE CAR IN PARK IN ORDER TO STOP. AIR BAGS DID NOT DEPLOY.

Jul 18, 2020

Crash: 1

Injuries: 1

ELECTRICAL SYSTEM,UNKNOWN OR OTHER

1 complaint

THE VEHICLE HAS AN INTERMITTENT ELECTRICAL PROBLEM WHICH CAUSES A CROSS TRAFFIC SYSTEM FAULT, BLIND SPOT SYSTEM FAULT AND THE LIFTGATE OR LIFTGLASS TO INDICATE THAT IT IS AJAR. HEN THESE FAULT THE SAFETY SYSTEMS ARE INOPERATIVE AND POSE A SAFETY CONCERN. THIS OCCURS WHILE IN MOTION AT BOTH ON BOTH CITY STREETS AND AT HIGHWAY SPEEDS. *TR

May 11, 2020

ELECTRICAL SYSTEM,STRUCTURE,UNKNOWN OR OTHER

1 complaint

THE RETRACTABLE/AUTOMATIC RUNNING BOARD ON THE PASSENGER SIDE INTERMITTENTLY DROPS DOWN WHEN THE CAR IS IN PARK AND IN A STATIONARY POSITION FOR A PERIOD OF TIME. (IE. 2-3 HOURS AT REST) WHEN I RESTART THE VEHICLE AND OPEN/CLOSE THE DOORS, THEN SHUT OFF THE VEHICLE, THE RETRACTABLE RUNNING BOARDS WILL GO BACK UP WHERE THEY BELONG...MOST OF THE TIME. SEVERAL DAYS LATER, THE SAME THING HAPPENS AGAIN. I TOOK THE VEHICLE IN FOR SERVICE (CRONIN FORD - HARRISON, OHIO) IN THE FALL OF 2019 AND THEY REPLACED THE RETRACTABLE RUNNING BOARD MOTOR ON THE PASSENGER SIDE ONLY. IN MARCH OF 2020, IT STARTED TO HAPPEN AGAIN, AFTER THE VEHICLE IS AT REST FOR 2-3 HOURS. I AM PLANNING TO TAKE IT IN FOR SERVICE AGAIN, BUT I'M CONCERNED THAT THIS WILL BECOME A RECURRING PROBLEM WELL AFTER THE WARRANTY PERIOD IS OVER.

Apr 23, 2020

ELECTRICAL SYSTEM,SERVICE BRAKES,ENGINE

1 complaint

EVEN THOUGH I HAVE PUT THE CAR IN PARK, IT STILL MOVES AND HAS HIT ME AND SOME OF THE PASSENGERS GETTING OUT THE CAR WITH THE DOORS AND OTHER PARTS OF THE VEHICLE ALMOST RUNNING US OVER. THE VEHICLE WAS PUT IN PARK ACCORDING TO DIAL. HOWEVER, IT STILL MOVED.

Sep 13, 2019

Injuries: 6

STEERING,WHEELS,SERVICE BRAKES

1 complaint

VEHICLE FRONT DRIVER SIDE TIRE/RIM/CYLINDER HAS A POPPING SOUND. IT POPS AS IF THE CALIBER OR BRAKES HAVE SOMETHING BROKE OR DIRT IN IT. I CAN HEAR THIS WHEN DRIVING SLOW AND WHEN IN REVERSE BACKING UP. ONLY HEAR SOUND WHEN DRIVING. BROUGHT THIS TO THE ATTENTION OF THE DEALERSHIP WHEN I PURCHASE THE VEHICLE, TOOK BACK TO DEALERSHIP TWICE AND THEY COULD NOT FIND OR FIX THIS PROBLEM.

Sep 12, 2019

STEERING,ELECTRICAL SYSTEM,ENGINE

1 complaint

TL* THE CONTACT OWNS A 2018 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE FAILED TO SHUT OFF AND THE CONTACT DISCONNECTED THE BATTERY. ALSO, THE RUNNING BOARDS FAILED TO RETRACT AND THE STEERING WHEEL PULLED TO THE LEFT AND RIGHT. THE CONTACT STATED THAT THE DRIVE CONTROL MALFUNCTION SERVICE REQUESTED, HILL DESCENT FAULT, ELECTRONIC LIMITED SLIP DIFFERENTIAL, REDUCED TORQUE, DRIVE CONTROL, PRE COLLISION ASSIST NOT AVAILABLE, SERVICE ADVANCETRAC, AND TRACTION CONTROL WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO THOROUGHBRED FORD (8501 N BOARDWALK AVE, KANSAS CITY, MO 64154, (816) 505-1818) AND SEEKINS FORD LINCOLN (1625 SEEKINS FORD DR, FAIRBANKS, AK 99701, (907) 459-4000) WHERE IT WAS DIAGNOSED THAT THE STEERING SENSOR NEEDED TO BE RESET AND THE STEERING WHEEL NEEDED TO BE ADJUSTED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER: CAS21880081. NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 500.

Jun 19, 2019

SUSPENSION,ELECTRICAL SYSTEM,SEAT BELTS

1 complaint

TAKATA RECALL. ON 4/29/19 THE 2ND ROW MIDDLE SEAT BELT WAS REPLACED AFTER HAVING BEEN IN THE SHOP 2X FOR DIAGNOSIS. IT WOULD NOT RELEASE OUT TO BUCKLE. IT KEPT SNAGGING ON ITSELF INSIDE. ON 6/11/19 THE VEHICLE WAS TAKEN IN TO BE DIAGNOSED FOR BAD STRUT. TURNS OUT 3 OF THE 4 WERE BAD AND NEED REPLACED. THE DEALERSHIP WOULD NOT REPLACE THE 4TH STRUT EVEN THOUGH SHE STATED ITS BEEN A BIG PROBLEM LATELY. ALSO THE LIFT GATE WAS INSPECTED AS IT OPENS AND CLOSES ON ITS OWN PERIODICALLY. THEY COULD NOT GET THE LIFT GATE TO RECREATE THE PROBLEM AND SINCE THE VEHICLE DIDNT THROW A CODE FOR IT THEY CANT DO ANYTHING ABOUT IT. I HAVE AN APPOINTMENT FOR 6/19/19 TO HAVE THE 3 STRUTS REPLACED AND THE LIFT GATE CHECKED AGAIN.

Jun 14, 2019

STEERING,ELECTRICAL SYSTEM,ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

FOLLOWING COMPUTER ISSUES THAT CAUSED THE FOLLOWING: BAD STEERING SENSOR (PLAY IN THE STEERING), TRACTION CONTROL WARNING, HILL DECENT WARNING, RUNNING BOARDS NOT WORKING, FORD SYNC FREEZING: RADIO, TEMP, BACK UP CAMERAS, PHONE NOT WORKING. MONITOR TURNS OFF AND ON WHILE DRIVING. MONITOR WILL NOT TURN OFF WHEN CAR PARKED.

Jun 12, 2019

POWER TRAIN,STRUCTURE

1 complaint

I WAS BACKING UP AND THE TRUCK TOOK OFF WITHOUT MY FOOT ON THE GAS PEDAL. I HAVE ABOUT 15K IN DAMAGE TO MY VEHICLE. I HAVE FOUND A FEW OTHERS THAT HAVE HAD THE SAME PROBLEM

May 01, 2019

Crash: 1

AIR BAGS

1 complaint

THE AIR BAG WARNING LIGHT IS ON WHICH MAY CAUSE THE AIRBAGS NOT TO FUNCTION PROPERLY. WE HAVE NOT HAD AN ACCIDENT TO CAUSE THE AIR BAG LIGHT ON THE DASHBOARD TURN ON. WE ARE TAKING IT TO THE DEALERSHIP LATER IN THE MONTH TO FIND OUT THE EXACT CAUSE OF THIS MALFUNCTION. BUT THE POTENTIAL OF AN ACCIDENT AND THE AIR BASS FAILING TO DEPLOY IS IN THE BACK OF MY MIND. PLEASE LOOK INTO THIS MATTER NOW SO IT PREVENTS ANY FUTURE FAMILIES BEING AFFECTED.

Jan 27, 2019

POWER TRAIN,VEHICLE SPEED CONTROL,SERVICE BRAKES

1 complaint

ELECTRONIC DIAL SHIFTER WILL AUTOMATICALLY SWITCH FROM DRIVE TO PARK IF THE VEHICLE START STOP BUTTON IS DEPRESSED WHEN THE CAR IS RUNNING. THE PARKING BRAKE ALSO AUTOMATICALLY SWITCHES ON AT THE SAME TIME. CONSIDER WHAT WOULD HAPPEN IF A 2018 FORD EXPEDITION IS TRAVELING ON A FREEWAY IN TRAFFIC AND THE START STOP BUTTON WERE ACCIDENTALLY DEPRESSED. THE CAR WOULD SHIFT INTO PARK, THE PARKING BRAKE WOULD ENGAGE AND THE DRIVER WOULD DECELERATE RAPIDLY FROM 65 MPH TO A STOP WITH NO NOTICE, LIKELY BEING REAR ENDED BY TRAFFIC IE; A SEMI TRUCK AT HIGHWAY SPEED. THE ELECTRONIC SHIFTER SHOULD STAY IN THE SELECTED GEAR WHEN THE START STOP BUTTON IS DEPRESSED AS A CONVENTION SHIFTER WOULD, ELECTRIC OR MECHANICAL. I DETERMINED THIS AFTER GOING TO A CAR WASH, PUTTING THE CAR IN NEUTRAL THEN DEPRESSING THE STOP BUTTON TO SAVE FUEL. THE CARIMMEDIATELY SHIFTED FROM NEUTRAL TO PARK AND ENGAGED THE PARKING BRAKE. I TESTED THE DRIVE, START BUTTON OFF, IMMEDIATELY SWITCHES TO PARK ON A FLAT STREET AT ZERO SPEED. I REALIZED AS AN ENGINEER THAT IF THIS HAPPENED AT SPEED A FATAL ACCIDENT COULD OCCUR. FORD CAN REMOVE THIS RISK WITH A SOFTWARE UPDATE TO THE ELECTRONIC SHIFTING, LEAVING THE CAR IN THE SELECTED GEAR IF THE START STOP BUTTON IS DEPRESSED.

Jan 05, 2019

2018 FORD Expedition EL Problems & Complaints

Complaints by Component

Frequently Asked Questions

How many problems does the 2018 FORD Expedition EL have?

What are the most common problems with 2018 FORD Expedition EL?

Where does this 2018 FORD Expedition EL problem data come from?

Other Years - FORD Expedition EL

Other FORD Models

Similar Brands