How many problems does the 2005 FORD F-350 have?

The 2005 FORD F-350 currently has 114 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2005 FORD F-350?

The most common problems reported for the 2005 FORD F-350 are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2005 FORD F-350 problem data come from?

All problem and complaint data for the 2005 FORD F-350 comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.

2005 FORD F-350 Problems

STEERING,SUSPENSION

13 complaints

Twice today, traveling at 75mph on highway [XXX] (northbound and then several hours later southbound) just north of Ardmore OK, I experienced a violent shaking of the steering wheel/front wheel shimmy. The vehicle was difficult to control due to the violent shaking that did not stop until the vehicle slowed to approximately 20mph. Once the shaking stopped the vehicle was okay to drive. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Feb 29, 2024

My 2005 F350 Diesel Pick up has suffered from the Ford death wobble on and off for the last 15 years. While navigating a left hand corner at speeds over 40 it begins to shake uncontrollably after hitting a small bump or pot hole until speed is reduced to 30mph or less. I have replaced bearings, uppper & lower ball joints, torque arms and other suspension parts without finding a cure.

Jul 04, 2023

Multiple times driving the truck at speed limit and hit small bump or a little bumpy part of road triggers the death wobble. Have to almost come to complete stop on highway to stop wobble.

May 30, 2022

The contact owns a 2005 Ford F-350. The contact stated while driving approximately 50 MPH, the vehicle started to shimmy. The contact stated that at the time of failure the steering wheel was very difficult to turn. The contact stated that after slowing down the vehicle operated normally. The contact stated that the brake warning light was illuminated. The vehicle was not repaired. The contact stated that she received notification in the mail of NHTSA Campaign Number: 20E090000 (Steering, Suspension, Equipment) however, her vehicle was not included in the recall. The contact stated that neither the dealer nor the manufacturer was notified of the failure. The failure mileage was unknown.

May 12, 2022

DEATH WOBBLE. TRUCK SHAKES VIOLENTLY WHEN TRAVELING +50 MPH, EMPTY, OR TOWING OR HAULING LOAD IN TRUCK BED. DOWNHILL BRAKING IS EXTREMELY DANGEROUS. TURNING WHILE BRAKING IS THE WORST.

Mar 30, 2020

+ 8 more complaints for this component

ENGINE

10 complaints

TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT THE VEHICLE MISFIRED AND CAUSED THE STEERING WHEEL TO SEIZE. ALSO, WHILE DRIVING VARIOUS SPEEDS, THE BRAKE PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO IMMEDIATELY STOP. THE VEHICLE WAS TAKEN TO FORMULA FORD LINCOLN (4318 MIDDLE RD, RUTLAND, VT 05701, (802) 773-9168) WHERE THE CAM PHASERS WERE REPLACED; HOWEVER, THE FAILURE RECURRED AFTER 176 MILES. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 63,000.

Nov 25, 2019

TL* THE CONTACT OWNS A 2005 FORD F-350. WHILE DRIVING 65 MPH, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND POWERED OFF THE ENGINE. THE VEHICLE WAS RESTARTED AND WAS ABLE TO DRIVE NORMALLY. LATER, THE VEHICLE STALLED AND FAILED TO RESTART. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED, BUT A FAILURE CODE COULD NOT BE FOUND. THE VEHICLE WAS NOT TAKEN TO A DEALER AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

Apr 02, 2019

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT ATTEMPTED TO RESTART THE VEHICLE, BUT WAS UNSUCCESSFUL. THE CONTACT HAD THE VEHICLE TOWED TO HIS HOME. A DIAGNOSTIC APPOINTMENT WAS SCHEDULED WITH GUESS FORD (457 STEUBENVILLE RD SE, CARROLLTON, OH 44615, (330)-627-7666). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THERE WERE NO RECALLS; THEREFORE, THE CONTACT WOULD HAVE TO PAY IN FULL FOR THE REPAIRS. THE FAILURE MILEAGE WAS 76,000. *TT CONSUMER STATED THIS WAS THE SECOND TIME IT STALLED. UPDATED 12/03/18*JB

Sep 17, 2018

TL*THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 55 MPH, THE ENGINE STALLED WITHOUT WARNING. THE CONTACT MANAGED TO COAST TO AN EMERGENCY LANE. THE VEHICLE WAS RESTARTED. HOWEVER, THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR A DIAGNOSIS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.

Mar 05, 2015

TL*THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 74 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT FOUR INJECTORS FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.

Feb 02, 2015

+ 5 more complaints for this component

FUEL SYSTEM, DIESEL

10 complaints

TL* THE CONTACT OWNS A 2005 FORD F350. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE FUEL FILTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 55,000. *TR

Dec 10, 2013

MERGED ON TO MCFARLAND BLVD. WITH SOUTH BOUND TRAFFIC TRUCK LOST POWER COULD NOT CONTROL VEHICLE OTHER TRAFFIC ALMOST RAN INTO THE TRUCK.HAD TRUCK TOWED TO DIESEL SHOP.COLUMBUS DIESEL SERVICE FOUND PAINT CHIPS IN FILTER REMOVED FUEL TANK ,COATING OF THE TANK WAS COMING OFF AND ENTERING THE FUEL SYSTEM THIS IS THE FACTORY TANK THAT CAME WITH THE TRUCK.. *TR

Aug 09, 2013

TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS THE VEHICLE WOULD EITHER STALL OR DECELERATE TO APPROXIMATELY 5 MPH. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP WHERE THEY WERE UNABLE TO DIAGNOSE THE FAILURE. AN INDEPENDENT MECHANIC THEN EXAMINED THE VEHICLE AND NOTICED THAT THERE WERE SILVER FLAKES SETTLING IN THE FUEL FILTER. THE INDEPENDENT REPAIR SHOP WAS THEN NOTIFIED AND THE CONTACT WAS INFORMED THAT THE SILVER FLAKES WERE A RESULT OF THE DELAMINATION OF THE FUEL TANK. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND THE CONTACT WAS INFORMED THAT DIESEL FUEL WAS CAUSING THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.

Jul 14, 2011

2005 F350 SUPERDUTY POWERSTROKE 6.0 DIESEL WITH 53,000 MILES CONTINUED TO ACCELERATE WITHOUT OPERATOR CONTROL NEARLY CAUSING REAR-END COLLISION WHILE DRIVING. OPERATOR COMPLETED A TURN AND ACCELERATED TO THE SPEED LIMIT AND WHEN OPERATOR RELEASED THE THROTTLE THE VEHICLE "TOOK OFF" AS IF THE ACCELERATOR HAD BEEN DEPRESSED AGAIN. OPERATOR CAME CLOSE TO REAR ENDING A PASSENGER CAR IN FRONT OF THE OPERATOR SO THE OPERATOR IMMEDIATELY APPLIED BRAKES AND PULLED OUT OF TRAFFIC WHILE TRUCK CONTINUED ATTEMPT TO ACELERATE. WHILE TRUCK WAS REVING AT HIGH RPM OPERATOR PUT VEHICLE IN "PARK" POSITION AND TURNED KEY TO OFF SHUTTING DOWN ENGINE COMPLETLY. ENGINE RESTARTED AND CONTINUE TO OPERATE NORMALLY AND CONTACTED AND DELIVERED VEHICLE TO THE SERVICING FORD DEALERSHIP. OPERATOR STATES THAT THE VEHICLE HAD PRIOR "FAILURE TO SHUT DOWN" AND "FAILURE TO DECEL" ISSUES BUT NO "DIAGNOSTIC CODE" WAS ESTABLISHED FOR DEALER TO USE AS WITH POSSIBLE CURRENT EVENT. *TR

Apr 30, 2011

I HAVE A 2005 FORD F-350 WITH A POWERSTOKE. IT ONLY HAS ABOUT 100,XXX MILES ON IT BUT THE FUEL TANK DELAMINATED AND CAUSED FIVE INJECTORS TO GO BAD THIS IS A SAFETY CONCERN. NOT TO MENTION A COSTLY FIX AND FORD CANT EVEN FILL THE TANK ORDERS ITS BEEN ON BACK ORDER FOR 6 WEEKS. THIS SHOULDN'T HAPPEN ON A TRUCK THAT IS ONLY 5 YEARS OLD. *TR

Apr 18, 2011

+ 5 more complaints for this component

STEERING

9 complaints

When driving 50 mph or above and hitting a bump in the road such as a bridge apron the truck develops an uncontrollable shimmy in the front end. It requires a firm grip from both hands to control the steering and lasts until the truck is slowed to under 20 mph and often until it is completely stopped. Luckily there hasn’t been another vehicle in the lanes next to me when this has occurred. If there had been it may have caused an accident. Tires are relatively new and the alignment is spot on. It feels like the same problem I had as a teenager in my 1959 Ford F100 when the king pins were worn.

Aug 09, 2021

MY 2005 HAS A VIOLENT FRONT END WOBBLE IF I HIT A BUMP WHILE TURNING RIGHT. WHEN I TOOK IT TO THE DEALER, I WAS TOLD TO OVER INFLATE MY TIRES. HE ALSO SAID THAT IT WAS A COMMON COMPLAINT WITH THIS MODEL. THE DEALER CALLED IT A " DEATH WOBBLE " AND TOLD ME TO MAKE SURE THAT I WAS HOLDING THE STEERING WHEEL TIGHT WHEN IT HAPPENS. THIS IS A REGULAR OCCURRENCE.

Feb 09, 2016

WHEN EVER THIS TRUCK HITS A BUMPY PART OF ROAD (E.G. POT HOLE, CRACK IN PAVEMENT, OR DEBRIS) THE VEHICLE (AND STEERING WHEEL) WILL SHAKE VIOLENTLY BACK AND FORTH FOR SEVERAL SECONDS (4 TO 5 SECONDS) OR UNTIL I SLOW TO SPEEDS AROUND 35MPH OR BELOW. THIS HAPPENS ON A REGULAR BASIS AND HAS HAPPENED SINCE I BOUGHT THE VEHICLE TWO YEARS AGO. THE TIRES ARE LIKE NEW, AND THE FRONT SUSPENSION COMPONENTS HAVE BEEN CHECKED AND DETERMINED TO BE IN GOOD USABLE CONDITION. SEARCHING THE WEB FOR POSSIBLE CAUSES OR FIXES OF THIS ISSUE, I HAVE FOUND THAT MANY OTHER PEOPLE ALSO HAVE THIS SAME PROBLEM, WITH LITTLE TO NO HELP COMING FROM SERVICE REPAIRS AT A DEALERSHIP. *TR

Mar 17, 2015

TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE VEHICLE STARTED TO JERK VIOLENTLY WITHOUT ANY WARNING. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE WAS 50,000 AND THE CURRENT MILEAGE WAS 250,000. UPDATED 2/26/14*CN

Jan 16, 2014

TL* THE CONTACT OWNS A 2005 FORD F350. THE CONTACT STATED THAT THE STEERING WHEEL WOULD SHAKE VIOLENTLY. THE VEHICLE WAS TAKEN TO A MECHANIC WHO AS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS THEN TAKEN TO THE DEALER WHO ALSO COULD NOT DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 24,000.

Aug 30, 2011

+ 4 more complaints for this component

ELECTRICAL SYSTEM

8 complaints

Vehicle stalls while driving and wont start again suddenly while operating. Fuel injectors won’t feed fuel line to restart or operate. Occasional start but then stalls continuously until battery dies from trying. Will start when priming the carburetor however will not stay running and stalls out.

Jun 14, 2024

TL* THE CONTACT OWNS A 2005 FORD F-350. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE SUDDENLY STALLED. AFTER, RESTARTING THE ENGINE, THE VEHICLE OPERATED NORMALLY; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (MATTHEWS FORD, 1101 WEST SW. EXPRESS DR., BROKEN ARROW, OK) WHERE IT WAS DIAGNOSED THAT THE ELECTRICAL WIRE HARNESS WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT NO ASSISTANCE WAS OFFERED. THE CONTACT WAS INFORMED BY THE MANUFACTURER THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM), ALTHOUGH IT EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 45,000. *TT *JS

Aug 03, 2018

THE INSTRUMENT CLUSTER AND RADIO CUT OUT FREQUENTLY WHILE THE VEHICLE IS RUNNING. THIS CAUSES THE SPEEDOMETER, TACHOMETER, FUEL GAUGE, THERMOSTATS, AND ODOMETER TO SHOW THERE IS NO POWER TO THEM AND THE NEEDLES RESTS AS THEY DO WHEN THE VEHICLE IS OFF. THE RADIO ALSO CUTS OUT DURING THIS TIME. THIS HAPPENS WHEN THE VEHICLE IS STATIONARY, MOVING, ON CITY STREETS, AND ON HIGHWAYS. THERE IS NO WARNING WHEN THIS HAPPENS. IT WILL STAY OFF FOR SECONDS TO MINUTES. CURRENTLY THERE IS NO RECALL FROM FORD. THERE IS INFORMATION ON THE INTERNET CONCERNING OTHERS WITH THE SAME PROBLEM SO THIS IS NOT A SINGLE VEHICLE ISSUE. I AM CURRENTLY UNABLE TO GET A STATE VEHICLE SAFETY INSPECTION DUE TO THE INSTRUMENTS NOT FUNCTIONING PROPERLY.

May 23, 2018

TL* THE CONTACT OWNS A 2005 FORD F-350. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE STALLED WITHOUT WARNING AND FAILED TO RESTART. THE CONTACT HAD THE VEHICLE TOWED. THE VEHICLE WAS NOT TAKEN TO THE DEALER NOR WAS IT DIAGNOSED AND REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT TO FILE A COMPLAINT IN AN ATTEMPT TO HAVE THE VEHICLE INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE APPROXIMATE FAILURE MILEAGE WAS 123,000.

Jan 26, 2017

AUG 1, 2014 FUEL INJECTION FAILURE, DUE TO FUEL INJECTION WIRE HARNESS CHAFING. SEPT 15 FUEL INJECTION FAILURE DUE TO FICM FAILURE RESULTING IN SEVERE LOSS OF POWER. VEHICLE BARELY MOVES, STRONG POSSIBILITY OF CRASH DUE TO VEHICLES UNEXPECTED SUDDEN LOSS OF POWER AND INABILITY TO MOVE. INCIDENTS CLOSELY RELATE TO RECALL 05V270000 FOR VEHICLE MANUFACTURED CLOSE TO SAME DATES. BELIEVE THAT RECALL SHOULD BE REOPENED AND EXTENDED TO INCLUDE ALL 6.0 DIESEL ENGINES. *TR

Sep 24, 2014

+ 3 more complaints for this component

ENGINE AND ENGINE COOLING

8 complaints

WHITE HEAVY SPOKE, LOSS OF POWER, PERFORMANCE, ENGINE STALLED ON MAJOR HIGHWAY AN EXTREMELY DANGEROUS SITUATION. DEALER STATED NOT FORD OR THEIR PROBLEM. CHARGES CLOSE TO $1,500 TO REPAIR. DEALER CLAIMS FAILED EGR VALVE.

Jul 06, 2012

TL*THE CONTACT OWNS A 2005 FORD F-350. WHILE TRAVELING 15 MPH THE CONTACT NOTICED THAT THE ENGINE HAD BEGAN TO RUN HOT AND WAS MAKING A WHINING NOISE. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHERE THE HEAD GASKET AND EGR COOLER HAD TO BE REPLACED. THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 60000.

Sep 08, 2010

TL* THE CONTACT OWNS A 2005 FORD F350. THE CONTACT STATED THAT THE EGR OIL COOLER FAILED AND NEEDED REPLACING. THE MANUFACTURER WOULD NOT PROVIDE ANY ASSISTANCE DUE TO THE VEHICLE BEING OUTSIDE OF FACTORY WARRANTY. THE VEHICLE WAS NOT BEEN REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 80,000.

Aug 20, 2010

TL*THE CONTACT OWNS A 2005 FORD F-350. WHILE DRIVING 40 MPH, THE CONTACT NOTICED THE SMELL OF COOLANT INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE EGR OIL COOLER WAS REPLACED. THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 81,000. UPDATED 9/13/10 *CN UPDATED 09/27/10

Jul 12, 2010

TL*THE CONTACT OWNS A 2005 FORD F-350. WHILE DRIVING BETWEEN 50-55 MPH, THE VEHICLE SHUT OFF COMPLETELY AND THE POWER STEERING AND BRAKES FAILED. THE CONTACT STATED THAT FORD SHOULD PAY FOR THE REPAIRS BECAUSE THE FAILURE WAS A MAJOR SAFETY ISSUE. THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE CURRENT AND FAILURE MILEAGES WERE 194,947.

Mar 30, 2009

+ 3 more complaints for this component

SUSPENSION

5 complaints

TL* THE CONTACT OWNS A 2005 FORD F-350. WHILE DRIVING OVER A BUMP IN THE ROAD, THE VEHICLE EXPERIENCED THE DEATH WOBBLE. THE FRONT END OF THE VEHICLE SHOOK UNCONTROLLABLY AND WOULD NOT STOP. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO MOUNTAIN VIEW FORD (301 E 20TH ST, CHATTANOOGA, TN 37408, (423) 756-1331) WHERE IT WAS DIAGNOSED THAT A NEW TRACK BAR WAS NEEDED. THE VEHICLE WAS THEN TAKEN TO MARSHALL MIZE FORD (5348 TN-153, HIXSON, TN 37343, (423) 875-2023) WHERE IT WAS DIAGNOSED THAT THE VEHICLE NEEDED A TRACK BAR. THE VEHICLE WAS REPAIRED; HOWEVER, THE REPAIR FAILED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 36,000.

Apr 05, 2019

2005 FORD F-350 DEVELOPS SEVER VIBRATION AND THE OSCILLATION OF THE STEERING WHEEL CAUSES SEVERE STEERING DIFFICULTY. THIS PROBLEM DOES NOT DISSIPATE UNTIL SPEED IS REDUCED TO APPROXIMATELY 40 MPH. OBVIOUSLY THIS IS VERY DANGEROUS ON A FAST MOVING FREEWAY WHERE SPEEDS CAN EXCEED 70 MPH. THE CONDITION IS ADDRESSED IN LITERATURE PROGRAM 09L02 LETTER DATED NOVEMBER 2011. THE VEHICLE HAS BEEN CHECKED AFTER AN EVENT AND THE TECHNICIAN HAS NEVER DISCOVERED A DEFICIENCY THAT HE CAN ATTRIBUTE TO THIS MALFUNCTION. THE TECHNICIAN HAS CHECKED ALL SUSPENSION, STEERING AND TIRE RELATED ITEMS. THE TIRES THAT ARE ON THE TRUCKS ARE LOAD RANGE E TIRES AND ARE PROPERLY INFLATED TO THE MAXIMUM PRESSURE PER THE MANUFACTURERS (BIG O) SPECIFICATIONS. ALL SUSPENSION AND STEERING PART ARE FACTORY INSTALLED OR OEM PARTS AND THE SHOCK ABSORBERS ARE HEAVY DUTY. *KB

Feb 03, 2012

2005 F350 DIESEL DUALLY THIS VEHICLE NEEDS TO BE RECALLED! THE LETTER THAT FORD SENT TO OWNERS IS NOT ACCURATE! IT IS NOT THE TIRE PRESSURE OF THE VEHICLE CAUSING THE SEVERE SHAKE! MY WHOLE TRUCK SHOOK PROFUSELY! IT WAS QUITE SCARY. AT POSTED HIGHWAY SPEED LIMITS IF THERE IS A SLIGHT BUMP IN ROAD YOU CAN BE SLOWING DOWN AN HIT A BUMP AND TRUCK BEGINS TO SHAKE OR GOING A AROUND A CURVE ON THE HIGHWAY AT 65MPH AND IF THERE IS A BUMP IN THE ROAD ON THE CURVE THE ENTIRE TRUCK SHAKES PROFUSELY. RECEIVED A LETTER FROM FORD STATING IT WAS TIRE PRESSURE BUT MY TIRE PRESSURE IS PERFECT. THIS IS A DEFECT THAT NEEDS TO BE RECALLED IMMEDIATELY STEERING BOX ROCKER ARM TIRE ROD SOMETHING BUT THIS TRUCK IS NOT RIGHT. I HAUL A 40FT TRAILER AND IF I HAD BEEN HAULING IT I WOULD BE DEAD ALONG WITH SEVERAL OTHER CARS I WOULD WIPED OUT PLEASE GET THIS VEHICLE RECALLED FOR SAFETY OF THE CONSUMER IT IS DEFINITELY NOT THE PROBLEM THAT FORD CLAIMS AT THIS POINT. MY TRUCK NEEDS TO BE REPAIRED AT THE COST OF FORD AND THIS DEFECT NEEDS TO BE RECALLED! PLEASE TAKE THIS COMPLAINT SERIOUSLY. SOMEONE WILL BE KILLED LIKE THIS. *TR

Sep 23, 2009

I HAVE A 2005 FORD F-350 4X4 DIESEL DUALLY TRUCK. SOON AFTER I BOUGHT THE TRUCK I EXPERIENCED A ROUGH SHIMMY IN THE FRONT END. WHEN I GO OVER BUMPS ON THE FREEWAY OR CITY STREETS THE FRONT END SHIMMY'S OUT OF CONTROL. THE TRUCK HAS BEEN TO THE DEALER ON SEVERAL OCCASIONS AND THEY HAVE TOLD ME THAT NOTHING IS WRONG. THIS IS NOT MY FIRST FULL SIZE TRUCK AND THIS IS THE FIRST ONE THAT ACTS LIKE THIS. SEVERAL TIMES IT HAS SENT ME INTO THE LANES BESIDE ME. I ALSO TOW A FIFTH WHEEL TRAILER AND IT AMPLIFIES THE PROBLEM. THIS PROBLEM OCCURS EVERY TIME I DRIVE THE VEHICLE AND FORD IN NOT RESPONSIVE TO THE PROBLEM. *TR

Jul 27, 2008

TL*THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT THE VEHICLE VIOLENTLY SHAKES WHILE DRIVING APPROXIMATELY 65 MPH. HE ALSO STATED THAT THE STEERING WHEEL SHAKES VIOLENTLY. THE FAILURES OCCUR WHEN THE VEHICLE DRIVES OVER A BUMPY ROAD. THE CONTACT STATED THAT THE VEHICLE WAS IN THE SHOP APPROXIMATELY A YEAR AGO FOR THIS SAME FAILURE. THE VEHICLE IS CURRENTLY AT THE DEALER. THE CURRENT MILEAGE IS 77,000 AND FAILURE MILEAGE WAS 60,000.

Jul 20, 2007

FUEL/PROPULSION SYSTEM

5 complaints

TL* THE CONTACT OWNS A 2005 FORD F-350. WHILE DRIVING APPROXIMATELY 65 MPH, THE ENGINE SEIZED WITHOUT WARNING. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO LEIF JOHNSON FORD (501 E KOENIG LN #1, AUSTIN, TX 78751 (512) 454-3711) WHERE IT WAS DIAGNOSED THAT THE FUEL LINER IN THE FUEL TANK CAUSED THE VEHICLE TO SEIZE. THE FUEL TANK WAS CORRODED AND CLOGGED THE INJECTORS. THE CONTACT STATED THAT THE FUEL TANK, FUEL INJECTORS, AND FUEL FILTERS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER ACKNOWLEDGED THE FAILURE, STATED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL, AND DID NOT OFFER ANY FURTHER ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

Sep 08, 2017

TL* THE CONTACT OWNS A 2005 FORD F-350. WHILE WALKING TOWARDS THE PARKED VEHICLE, THE CONTACT NOTICED THAT THE REAR PORTION OF THE FUEL TANK WAS SEPARATED FROM THE FRAME DUE TO A RUSTED FUEL TANK STRAP. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 174,000.

Dec 01, 2016

POWER SURGE. STOPPED WAITING AT LIGHT FELT LIKE I WAS HIT FROM BEHIND, VERY QUICK UNEXPECTED SURGE FORWARD, IT ALSO OCCRURES WHILE DRIVING BUT THE EFFECT IS NOT STRONG, MORE NOTICEABLE WHEN BACKING.

Aug 10, 2016

TL* THE CONTACT OWNS A 2005 FORD F-350. WHILE DRIVING 65 MPH, THE VEHICLE DECELERATED ON ITS OWN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL SYSTEM NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 125,900.

Jan 05, 2015

TL* THE CONTACT OWNS A 2005 FORD F-350 SUPER DUTY. THE CONTACT STATED WHILE AT A STOP LIGHT THE VEHICLE STALLED. THE CONTACT DID NOT TAKE THE VEHICLE TO A DEALER OR A LOCAL MECHANIC. THE CONTACT CALLED THE MANUFACTURER REGARDING THE NHTSA CAMPAIGN NUMBER 05V266000 (FUEL SYSTEM); HOWEVER, THEY STATED THE VEHICLE DID NOT HAVE ANY RECALLS. THE FAILURE MILEAGE WAS 172,456.

Oct 10, 2013

ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE

4 complaints

WHILE PULLING A 30 FOOT TRAVEL TRAILER TUCK SUDDENLY DIED CAUSING IMMEDIATE LOSS OF STEERING AND BRAKING POWER ON A VERY BUSY HIGHWAY NEARLY CAUSING AN ACCIDENT. HAD IT TOWED TO A DIESEL SHOP WHO SCANNED TO FIND IT TO BE THE HIGH PRESSURE OIL AND FUEL PUMPS. THEY SAID THEY HAVE DONE REPEATED REPAIRS ON THE SAME ENGINE WITH THE SAME PROBLEMS IN THE PAST. VERY COSTLY REPAIR OVER $3000 AND 5 DAYS TO DO. *TR

Mar 23, 2012

ISSUE 1 - FUEL SPILLING OUT OF COOLANT SYSTEM. FUEL SPILLING ONTO EXHAUST COMPONENTS AND COATING ENGINE AND UNDERSIDE OF VEHICLE. CREATED A FIRE HAZARD. CREATED AN ENVIRONMENTAL HAZARD. THIS COULD HAVE RESULTED IN SEVERE INJURY OR DEATH IF A FIRE HAD STARTED.

Mar 04, 2011

TL*THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, FOUR FUEL INJECTORS MALFUNCTIONED WHICH CAUSED THE EXHAUST TO EMIT SMOKE AND THE VEHICLE TO STALL. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE RADIATOR WAS REPLACED. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 83,000.

Nov 17, 2010

TL*THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT THE FUEL INJECTION MODULE AND RELAY SWITCH FAILED. THE VEHICLE WOULD NOT DRIVE MORE THAN 10 MPH WITHOUT BLACK SMOKE COMING FROM THE EXHAUST. THE CONTACT REPAIRED THE VEHICLE. THE VEHICLE HAD A HIGH PRESSURE OIL LEAK, WHICH LED TO THE FAILURE OF THE RELAY SWITCH THIS REPAIR WAS RESOLVED UNDER WARRANTY. THE FUEL INJECTORS WERE ALSO FAULTY AND WERE REPAIRED UNDER WARRANTY THREE TIMES. A MECHANIC STATED THAT THE FAILURES WOULD CONTINUE. . THE CONTACT IS CONCERNED ABOUT THE SAFETY OF HER VEHICLE. THE CURRENT AND FAILURE MILEAGES WERE 99,970.

Jan 20, 2009

FUEL SYSTEM, GASOLINE

4 complaints

MY 2005 F350 HAS A FUEL FAILURE AND WHEN I TOOK IT TO THE DEALER THEY SAID THAT 5 INJECTORS HAD FAILED AND I NEEDED THEY BLAME IT ON BIOFUEL, I HAVE ONLY USED ON ROAD DIESEL AND I HAVE OWNED THIS TRUCK SINCE IT HAD 25,000 MILES ON IT. AT THIS POINT IT IS $6000 TO REPAIR AND OF COURSE THERE IS NO WARRANTY ON IT. THIS IS A MAJOR CONCERN BECAUSE THIS TRUCK CARRIES EXTREME LOADS AT HIGH SPEEDS AND A FUEL FAILURE AT 65 OR 70 WILL CAUSE YOU TO LOSE POWER STEERING AND BRAKING ABILITY. WHEN YOU ARE CARRYING A BACKHOE AND HAVE A TRAILER THAT WEIGHS 6000LBS THE TOTAL WEIGHT OF THE WHOLE RIG IS RIGHT AT 35,000 POUNDS. THAT IS ENOUGH TO TAKE OUT AT LEAST 6 OR 7 CARS THAT HAVE STOPPED IN FRONT OF YOU. THIS NEEDS TO BE FIXED ASAP. *TR

Mar 08, 2012

TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT THE VEHICLE STALLED WHILE DRIVING 20 MPH. UPON RESTART, THE VEHICLE OPERATED AS NORMAL. THE CONTACT EXAMINED THE VEHICLE AND STATED THAT THE FUEL TANK WAS DELAMINATING AND CLOGGING THE FUEL FILTERS. THE VEHICLE WAS NOT DIAGNOSED, NOR REPAIRED, BY THE DEALER. THE FAILURE MILEAGE WAS 49,500 AND THE CURRENT MILEAGE WAS 50,200.

Feb 15, 2012

TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT THE FUEL TANK ON THE VEHICLE WAS ERODING AND CAUSING THE VEHICLE TO LOOSE POWER INTERMITTENTLY WITHOUT WARNING. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS INFORMED THAT THE FUEL TANK WOULD NEED TO BE REPLACED IN ORDER TO CORRECT THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 55,000.

Jan 10, 2011

TL*- THE CONTACT OWNS A 2005 FORD F-350. WHILE DRIVING AT 25-30 MPH THE VEHICLE LOST POWER. THE CONTACT HAD THE VEHICLE TOWED TO THE DEALERSHIP AND THE DEALERSHIP REMEDIED THE ISSUE BY REPLACING THE HIGH PRESSURE CUP LINK ON THE INJECTOR ACTIVATION SYSTEM. THE CONTACT FOUND NUMEROUS COMPLAINTS ONLINE ABOUT THE FUEL SYSTEM ON THIS YEAR MAKE AND MODEL VEHICLE. THE CONTACT FEELS THIS WAS A MAJOR SAFETY ISSUE BECAUSE THE VEHICLE COULD CRASH INTO ANOTHER VEHICLE IF ALL THE POWER IS LOST. THE CURRENT MILEAGE WAS 112,000 AND FAILURE 99,000.

Apr 22, 2009

UNKNOWN OR OTHER

2 complaints

Oil leaking from more than 4 parts of the engine and was told it’s normal for this model. Also, when driving over a bump or uneven pavement the trucks steering and suspension drives out of control.

Jan 11, 2022

Once I get up to 55-60 mph it just shakes really bad, I have had ball joints replaced bought new tires and it still shakes

Dec 21, 2021

ENGINE,FUEL/PROPULSION SYSTEM

2 complaints

CAME UP WITH A CODE TO REPLACE T.P.S. I REPLACED TPS NOW VEHICLE IS HAVING PROBLEMS IDLING . I CONTACTED FORD EXPLAINED TO THEM MY SITUATION. I WAS TOLD BY 3 DIFFERENT PEOPLE THAT WHENEVER PEOPLE WITH A 6.8 V10 HAVE THE CODE TO REPLACE T.P.S THEY END UP REPLACING THE WHOLE E.T.B. IS THERE A RECALL FOR THE THROTTLE BODY ?

May 30, 2017

I HAVE A 40 FT TOY HAULER I PULL WITH THE F350, GOING UP HILL AND ALL SYSTEMS FAIL. BUT LEFT ON THE SIDE OF THE MOUNTAIN RD I WAS TRAVELING. A FUEL RAIL IS DISCOVED GONE BAD, BILLOWS OF WHITE SOME PRIOR TO SYSTEM SHUT DOWN. $2800.00 REPAIR. TWO WEEKS LATER ANOTHER MOUNTAIN PASS TRUCK OVER HEATS CAUSING SYSTEM FAILURE. COME TO FIND OUT $10,000 DOLLARS LATER IN REPAIRS ALONE NOT, TALKING HOTEL, RENTAL CAR, AND DELAY OF TRIP FOR NINE DAYS. BUT THE PHIL LONG FORD DEALERSHIP NEW ABOUT THE COSTLY REPAIRS AND FAILS TO INFORM CUSTMOR.. LEADING HIM TOO A TOTAL OF $7300.00 IN REPAIRS. TOTAL REPAIRS $10,100. THANKS PHIL LONG FORD, COLORADO SPRINGS, FOR NOT INFORMING CUSTOMERS OF THE COSTLY REPAIRS BUT KNOWING THEY WHERE THERE. DRAGING HARD WORKING AMERICANS THOUGH THE DIRT... GREAT BUNCH OF GUYS. NOT... *TR

Jun 02, 2014

STEERING,SUSPENSION,WHEELS

2 complaints

DEATH WOBBLE. 1ST TIME IT HAPPENED WAS ENTERING THE HIGHWAY OFF THE RAMP AND ACCELERATING TO MERGE INTO TRAFFIC AND GOING OVER THE OVERPASS THE BRIDGES IN MASS. ARE A MESS, ANY WAY, WHEN I DROVE THOSE SERIES OF BUMPS AT ABOUT 60-65 MPH IN A TRUCK IT GETS BUMPY ANYWAY BUT ALL OF A SUDDEN THE STEERING WHEEL, AND THE TRUCK STARTED VIOLENTLY SHAKING OUT OF CONTROL SO BAD I LOST COMPLETE VISION IT WAS SHAKING SO BAD WITH NO CAPABILITY OF STEERING THE TRUCK..INSTINCTIVELY I APPLIED THE BRAKES NOT EVEN CHECKING TO SEE WHAT WAS BEHIND ME AS IT WAS SHAKING SO BAD, YOU CANT TURN AROUND, YOU CAN NOT SEE OUT THE MIRRORS. AS I STATED YOU KIND OF LOSE VISION AND EVERYTHING GOES BLURRY BECAUSE YOUR SHAKING IN THE VEHICLE SO BAD. A QUICK GOOGLE AND YOU FIND THIS HAPPENS TO MANY MANY OWNERS OF THIS VERY THE SAME TRUCK. IN FACT FORD SENT ME A LETTER STATING THEY KNEW ABOUT IT AND TO MAKE SURE WE HAVE THE CORRECT AIR PRESSURE. I USE A $50 AIR PRESSURE GAUGE, THE AIR PRESSURES NOT THE PROBLEM. IT WAS STILL HAPPENING ANYTIME YOU GO OVER BIG BUMPS OR A SERIES OF SMALLER BUMPS WILL SET IT OFF WHILE DRIVING ON THE HIGHWAY OR OVER 60 MPH. IT DOESN'T HAPPEN TO US AT SLOWER SPEEDS. THIS IS AN EXTREMELY DANGEROUS DEFECT.

Sep 04, 2016

WHILE TRAVELING ON THE HIGHWAY AT 65-70 MPH MY VEHICLE WILL GO INTO A VIOLENT SHIMMY IF IT HITS ANY SORT OF ROAD BUMP (SUCH AS BRIDGE EXPANSION). THIS HAPPENS EVERYDAY IN THIS VEHICLE. IT WILL NOT GO AWAY UNTIL I SLOW THE VEHICLE DOWN TO 45 MPH. *TR

Jul 06, 2012

ENGINE AND ENGINE COOLING,FUEL SYSTEM, DIESEL

2 complaints

CPSC: 2005 F-350. CONSUMER STATED THE 6.0 DIESEL MOTOR IS NO LONGER WORKING DUE TO A BUILDUP IN THE GAS TANK, OR OIL SYSTEM. *SS THE CONSUMER STATED AFTER THE VEHICLE WAS FIXED, IT BROKE DOWN AGAIN. *JB

Feb 02, 2016

TL*THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH, THE DIESEL ENGINE OVERHEATED WITH SMOKE COMING FROM THE EXHAUST PIPE. THE VEHICLE WAS DRIVEN TO THE SIDE OF THE ROAD. THE ENGINE WAS TURNED OFF, AND RESTARTED AFTER WAITING UNTIL THE ENGINE COOLED DOWN. THE VEHICLE RESUMED OPERATION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE FAILURE WAS CONTRIBUTED TO THE OIL COOLER AND EXHAUST GAS RECIRCULATION (EGR). THE VEHICLE WAS REPAIRED. THE MECHANIC ADVISED REPLACEMENT OF THE OIL PUMP AND FUEL INJECTORS. THE FAILURE MILEAGE WAS 160,000. THE CURRENT MILEAGE WAS 160,200.

Apr 07, 2010

Fire: 1

POWER TRAIN

2 complaints

TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING TRANSMISSION FLUID FROM A SEAL IN THE TORQUE CONVERTER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN ADVISED THE CONTACT THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 150,000 AND THE CURRENT MILEAGE WAS 168,000.

Dec 04, 2012

TRANSMISSION FLUID WAS LEAKING OUT FROM UNDER TRUCK AFTER I STARTED IT TO LET WARM UP. HAD IT TOWED TO THE GARAGE ONLY TO FIND OUT THAT A SNAP RING INSIDE THE TRANSMISSION HAD WORN A HOLE IN THE TRANSMISSION CASING. THIS COULD HAVE BEEN REAL BAD IF I HAD NOT LET THE TRUCK WARM UP AS I LIVE ON A HILL AND THE TRANSMISSION FLUID WAS COMING OUT SO FAST I AM SURE THE ROAD WOULD HAVE BEEN COVERED. I CHECK TO SEE IF FORD HAD RECALLED THIS PROBLEM BUT THEY DID NOT, EVEN AS THERE ARE MANY COMPLAINTS ON THE FORD FORUM WEBSITE. ALL I CAN SAY IS THERE WILL NOT BE ANOTHER FORD IN MY LIFE AFTER I REPLACE THIS TRUCK. *TR

Dec 09, 2011

TIRES

2 complaints

TIRE BELT INSIDE FELL APART AND CAUSED FLAT TIRE. TIRES BOUNCE EVEN AFTER BEING BALANCED OVER AND OVER SHOWS TIRES ARE BALANCED BUT TIRES BOUNCE ON ROAD. *TR

Oct 31, 2012

TL* THE CONTACT OWNS A 2005 FORD F-350 WITH CONTINENTAL TIRES, TIRE LINE SIZE 275/70/18. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, HE HEARD A LOUD NOISE AND THE VEHICLE STARTED JERKING VIOLENTLY. THE CONTACT NOTICED THAT THE PASSENGER SIDE REAR TIRE SIDEWALL WAS PEELING OFF. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO DIAGNOSED THAT ALL FOUR TIRES NEEDED TO BE REPLACED BECAUSE THE SIDEWALL WAS CRACKED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE TIRES WERE REPLACED. THE DOT NUMBER WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 24,000 AND THE CURRENT MILEAGE WAS 26,000. UPDATED 8/30/11 *CN THE CONSUMER STATED THE TIRES WERE INSPECTED AND IT WAS DETERMINED THEY WERE FAULTY. UPDATED 09/26/11

Jul 29, 2011

PARKING BRAKE

2 complaints

OCCURRING SINCE VEHICLE PURCHASED NEW ON JULY 9, 2005 WITH SIX YEAR EXTENDED WARRANTY. THE FAILURE IS THAT THE PARKING BRAKE DOES NOT WORK PROPERLY DESPITE REPEATED ATTEMPTS BY TWO DEALERS TO AS THEY SAY "ADJUST" IT. THE BRAKE WORKS AND ACTUATES 1-2 TIMES OUT OF 10 AND DOES NOT WORK IN REVERSE EVER. DEALER TOLD ME IT IS NOT DESIGNED TO WORK IN REVERSE AT ALL AND WILL NOT HOLD IN REVERSE. THE DEALERS SEE NO DEFECT AND HAVE NEVER REPLACED ANY PARTS. THE BRAKE LINING IS IN EXCELLENT CONDITION. DUE TO THIS SITUATION I SUSPECT IT IS SIMPLY A MANUFACTURER DEFECT OR DESIGN FLAW WITH SERIOUS SAFETY IMPLICATIONS IF THE TRANSMISSION PARK PIN FAILED. *TR

Aug 23, 2011

TL*THE CONTACT OWNS A 2005 FORD F-350. WHILE DRIVING APPROXIMATELY 35 MPH, THE REAR DRIVER SIDE TIRE SUDDENLY LOCKED WHICH CAUSED THE VEHICLES REAR END TO SLIDE; HOWEVER, THE CONTACT WAS ABLE TO CONTROL THE VEHICLE AND AVOID A CRASH. THE DEALER STATED THAT THE PARKING BRAKE ASSEMBLY NEEDED TO BE REPLACED. THE CONTACT PREVIOUSLY NOTICED THAT THE PARKING BRAKE INTERMITTENTLY FAILED TO FUNCTION PROPERLY. THE CURRENT AND FAILURE MILEAGES WERE 59,000.

Jan 04, 2010

AIR BAGS

1 complaint

The contact owns a 2005 Ford F-350. The contact stated while driving approximately 60-65 MPH and coming up to a bridge, the contact stated that the roadway was a bit wet from ice and rain, and the contact stated that the vehicle ahead entered the bridge and started skidding, so the contact let up off the accelerator pedal; however, when the vehicle entered the bridge, the vehicle started sliding and the contact lost control of the vehicle and crashed head-on into the concrete barrier surrounding the bridge and broke the two picking eyes that was welded unto the front sub frame of the vehicle. The contact stated that the front bumper was severely damaged, and he was concerned that that the air bags had failed to deploy. The contact stated that his chin struck the steering wheel, and his neck was hyper-extended. The contact sustained neck and shoulder injuries. The contact had not received medical treatment at the scene and was not transported to the local medical center for treatment. The contact stated that a Police report was filed and he received paperwork to request a copy of the Police report. The vehicle was towed to a local tow yard. The vehicle was later towed to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 228,000.

Apr 01, 2025

Crash: 1

Injuries: 1

ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

The all very common issues with the year f350 and the 6.0 l. Engines, are as such. The malfunctioning FICM. THE high and low oil coolers, the inter coolers and head studs. Also leaking break fluid .

Apr 29, 2022

SUSPENSION,POWER TRAIN,SERVICE BRAKES

1 complaint

[XXX] who performs automotive work out of his residence [XXX] and [XXX] of [XXX] have worked on this vehicle to spite the customer and to gouge the customer in unnecessary fraudulent repairs. They have deliberately set this vehicle up to fail with the braking system, the 6.0 engine being rebuilt to no avail, and constant driving problems such as pulling to the right and the left when brakes applied, constant overheating, constant oil temperature overheating, shuttering at highway speed, transmission failure, air conditioning failure, coolant system failure, electrical system failure, and every system that they have repaired, continues to fail. They specifically performed work on the electrical wiring and truck keeps blowing fuses. They performed work on the transmission and the transmission failed shortly after. They performed work on the engine and deleted illegally all the emissions EGR pollutant controls. They installed faulty wiring for the electric trailer brake controls and the electronic speed controls. They tampered with the air conditioning system causing the compressor to blow out, send metal through the a/c lines, and the belt stopped turning causing the serpentine belt to break, tear the fan shroud apart and shred. They also installed a trailer brake controller that was aftermarket and it caused brake loss and intermittent failure with the service brake system and speed control. Domingo also tuned the computer to make the truck output 550 horsepower which caused the new engine to fail prematurely and the transmission to fail as well. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Oct 17, 2021

Crash: 1

Fire: 1

ELECTRICAL SYSTEM,SERVICE BRAKES,ENGINE

1 complaint

[XXX], [XXX] approx age 40 lives and works at [XXX].[XXX] can also control the computers to cancel out and delete the use of catalytic converters, delete the use of DEF intake, delete the use of DPF particulate filters, and not react to controls such as manual braking or acceleration because the computer is controlling when and not the driver. [XXX] strictly states that he cannot have any emissions controls such as EGR, DEF, DPF, catalyst, or any pollutant controls. [XXX] intentionally set it up to have flaws and be dangerous for one reason: to get the customer to keep returning again and again with vehicle problems, wiring electrical problems, performance problems, overheating problems, and never ending engine problems not to mention transmission problems because the transmission could not handle the increased output of the engine. The hydroboost and ABS module and master cylinder that controls the brakes can be easily rigged so that when the driver stomps on the brakes, there is no braking action whatsoever for a 3-5 second delay before skidding the tires and locking the brakes. [XXX] altered the hydroboost and ABS module and master cylinder and the electronic controls to the braking system. [XXX] [XXX] partner admitted the hydrobooster and master cylinder was the problem because he admitted what [XXX] did as sabotage to the customer’s truck. [XXX] deletes the DPF and DEF and the electronics rewiring the truck. [XXX] has a pattern of keeping customers vehicles for excessively long periods of time: 42 days to change batteries, change fuel pump change PCM fusebox and rewire truck. [XXX] has removed the all the catalytic converters and he has removed all the EGR and emissions pollutant controls on [XXX]. [XXX] has sabotaged this truck’s braking system, electrical systems, fuse box wiring, electronic braking wiring, accelerator electronic control. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Oct 17, 2021

Crash: 1

Fire: 1

Injuries: 1

ELECTRICAL SYSTEM,EXTERIOR LIGHTING,FUEL/PROPULSION SYSTEM

1 complaint

WHILE DRIVING DOWN THE HIGHWAY(45-55MPH) VEHICLE DASH LIGHTS, RADIO, WINDOWS ALL STOP WORKING. THEY COME BACK ON RANDOMLY. NO CHANGE TO LITTLE CHANGE WHEN RE-STARTING. VEHICLE ALSO LOSES POWER AND THE ENGINE SEEMS TO PAUSE AND GO, OVER AND OVER LIKE IT'S STRUGGLING. I'VE TAKEN IT TO SEVERAL FORD CERTIFIED MECHANICS WHO ARE BAFFLED.

Jul 03, 2019

ELECTRONIC STABILITY CONTROL (ESC),FUEL/PROPULSION SYSTEM

1 complaint

FICM AND ICP SENSOR. I WOULD BE DRIVING DOWN THE ROAD AND MY VEHICLE WOULD CUT OFF ON ME WHILE ON THE STREET. IT WOULD TAKE ABOUT FIFTEEN MINUTES OR MORE TO START BACK UP(HOT START). I'VE ONLY HAD THE VEHICLE FOR A YEAR.

Aug 03, 2018

ELECTRONIC STABILITY CONTROL (ESC),ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

THE GAS TANK HAS A DEFECT IT EPOXY LINER IN GAS TANK CORRODES AND PLUGS UP THE FILTER EJECTOR AND SHUT TRUCK DOWN AND RUST OUT FILTERS. THE TRUCK WAS BEEN DRIVEN WHEN IT SHUT DOWN , TOOK TRUCK TO FORD DEALER, WAS TOLD GAS TANK IS ERODED AND HAS PLUG UP SYSTEM INCLUDING INJECTORS, WILL BE $8000.00 TO FIX, THAT THERE WASNT A CURRENT RECALL ON ITEM, BUT THAT FOR KNOW PROBLEM EXIST.

Sep 08, 2017

ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

1 complaint

TL* THE CONTACT OWNS A 2005 FORD F-350. WHILE ATTEMPTING TO START THE VEHICLE, IT FAILED TO START. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL INJECTION CONTROL MODULE, SENSOR, AND TURBO HOSES FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. A DEALER WAS NOT CONTACTED. ALSO, WHILE DRIVING 30 MPH, THE ENGINE BEGAN TO REV AND THE CONTACT HAD TO BRAKE TO STOP THE VEHICLE FROM SURGING FORWARD AND COLLIDING WITH THE PRECEDING VEHICLE. THE VEHICLE CONTINUED TO SURGE AS THE CONTACT DROVE. THE CONTACT PULLED OVER AND TURNED OFF THE VEHICLE. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE INJECTION CONTROL PRESSURE SENSOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF BOTH FAILURES AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

Aug 03, 2017

EXTERIOR LIGHTING

1 complaint

WHILE DRIVING ON THE INTERSTATE IN THE EVENING WITH OUR HEADLIGHTS ON, WE HAD TO BE PULLED OVER BY THE STATE POLICE TO INFORM US WE HAD ABSOLUTELY NO REAR RUNNING LIGHTS. UPON TROUBLESHOOTING THE PROBLEM I FOUND IT IS MOST LIKELY THE SAME AS RECALL NO. 11C18 MULTI-FUNCTION SWITCH. OUR MECHANIC ALSO AGREED THIS IS THE PROBLEM. BUT FORD SAYS OUR VIN # IS NOT INCLUDED IN THE RECALL. I HAVE SINCE SEEN TWO OTHER TRUCKS IDENTICAL TO OURS WITH NO REAR LIGHT AT NIGHT WHILE YET THEIR HEAD LIGHTS ARE ON.

Sep 04, 2016

SUSPENSION,ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED WHILE DRIVING AT APPROXIMATELY 65 MPH, THE VEHICLE VIOLENTLY SHOOK. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THE VEHICLE HAD A FRONT END OSCILLATION AND THAT TRACK BAR, STABILIZER LINK, AND UPPER AND LOWER BALL JOINTS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 127,000.

May 05, 2016

STEERING,SUSPENSION,ENGINE

1 complaint

TL* THE CONTACT OWNS A 2005 FORD F-350. WHILE DRIVING 45 MPH, THE VEHICLE WOBBLED. THE STEERING VEERED TO THE LEFT WHEN THE WHEEL WAS TURNED TO THE RIGHT AND VICE VERSA. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FRONT TIE RODS, FRONT STABILIZER BARS, GEAR BOX, AND MULTIPLE PARTS ON THE FRONT OF THE VEHICLE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. IN ADDITION, WHILE DRIVING 65 MPH, THE VEHICLE LOST POWER. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE INJECTORS, CAM SHAFT SENSOR, AND THE WIRING HARNESS FOR THE INJECTORS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 102,000.

Jan 12, 2016

FUEL SYSTEM, DIESEL,POWER TRAIN,ENGINE

1 complaint

I HAVE A 2005 FORD F350 DIESEL POWERSTROKE THAT HAS THE FUEL TANK LINING FALLING OFF AND ITS GOTTEN TO MY FUEL LINES AND FUEL PUMP CAUSING THE TRUCK TO COME TO A COMPLETE STOP WHILE I WAS DRIVING DOWN THE FREEWAY HAULING A 12FT TRAILER WITH A 10000 LBS TRACTOR ON IT. I HAD TO GET IT TOWED TO A SHOP WHERE THEY REPLACED THE FUEL PUMP AND FILTERS. ONE MONTH LATER IT DID THE SAME THING WHILE ON THE HIGHWAY AGAIN IT JUST DIED THE MECHANIC SAYS MY FUEL TANK IS THE PROBLEM THE LINING INSIDE THE FUEL TANK IS CHIPPING AWAY AND IT HAS GOTTEN TO THE FUEL SYSTEM AGAIN THIS IS A FREQUENT PROBLEM WITH FORD DIESEL TANKS AND THEY WONT TAKE RESPONSIBILITY. THIS SECOND TIME AROUND I AM HAVING TO REPLACE FUEL INJECTORS AND THE FILTERS AGAIN.

Jan 17, 2015

FUEL SYSTEM, DIESEL,FUEL SYSTEM, OTHER

1 complaint

TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH, THE ENGINE STALLED WITHOUT WARNING. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER ON SEVERAL OCCASIONS WHERE IT WAS DIAGNOSED THAT THE MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. ON ANOTHER OCCASION THE VEHICLE WAS TAKEN TO THE DEALER, WHERE IT WAS DIAGNOSED THAT THE PRESSURE UNIT FOR THE DIESEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,000.

Oct 10, 2014

SERVICE BRAKES, HYDRAULIC,ENGINE

1 complaint

THIS VEHICLE HAS HAD NUMEROUS ENGINE FAILURES WHICH I WILL LIST BELOW. I SPEND ALOT OF TIME IN RURAL LOCATIONS BETWEEN 50 AND 100 MILES FROM ANY SERVICE FACILITIES IN ALL KINDS OF WEATHER. USUALLY THERE IS NOT ANY CELL SERVICE AVAILABLE. IT IS ONLY A MATTER OF TIME BEFORE I OR SOMEONE IS STRANDED IN BAD WEATHER BECAUSE OF THE POOR ENGINEERING ON THE 6.0 LITER DIESEL THAT FORD INSTALLED IN MY VEHICLE. THIS COULD WELL BE LIFE THREATENING AND LEAD TO DEATH IN THE FUTURE. 6/12/06 TURBO FAILURE-COVERED BY WARRANTY BY FORD - 20000 MILES 7/15/06 RECALL ON COMPUTER-COVERED BY WARRANTY BY FORD- 21000 MILES 4/8/11 EGR COOLER BLEW OUT- OUT OF POCKET COST $1703.46- 90619 MILES 8/28/12 INJECTORS FAILED- OUT OF POCKET COST $2178.09- 110732 MILES 8/30/12 REAR WHEEL SEAL AND EMERGENCY BRAKE FAILURE- OUT OF POCKET COST- $703.06- 111423 MILES 10/12/12 TURBO FAILURE AGAIN- OUT OF POCKET COST $2577.75- 113473 MILES YOU CAN SEE THE ONGOING THEME HERE AND WHEN I TALK TO FORD THEY SAY "SORRY BUT WE HAVE NO RECALLS AND NO CUSTOMER SERVICE HELP AT THIS TIME." THEY NEED TO TAKE RESPOSIBILITY BEFORE SOMETHING HAPPENS AND IT PUTS PEOPLES LIVES AT RISK. AS THE OWNER OF THIS VEHICLE I WOULD LIKE TO BE INCLUDED IN ANY CLASS ACTION LAWSUITS AGAINST FORD FOR NOT TAKING RESPONSIBILITY FOR THE 6.0 LITER ENGINEERING DISASTER THAT THEY CREATED. HOPEFULLY SOMEONE WILL MAKE THEM STEP UP AND PROVIDE THE BUYERS OF THESE ENGINES THE HELP THEY NEED AND DESERVE. *TR

Oct 16, 2012

SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING,FUEL SYSTEM, DIESEL,POWER TRAIN,ELECTRICAL SYSTEM

1 complaint

TL* THE CONTACT OWNS A 2005 FORD F350 SUPER DUTY. THE CONTACT STATED THAT THE VEHICLE STALLED NUMEROUS TIMES WITHOUT WARNING WHILE DRIVING AT ANY SPEED. THE VEHICLE WAS TAKEN TO THE DEALER NUMEROUS TIMES FOR THE FAILURE. THE DEALER REPLACED THE FUEL INJECTORS, THE TURBO CHARGER WAS REPLACED FOUR TIMES, THE HEAD GASKETS, AND THE REAR END RINGS HOWEVER THE FAILURE WAS NOT CORRECTED. THE VEHICLE CONTINUED TO STALL WITHOUT WARNING AND THE ENGINE COULD NO LONGER BE STARTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM: WIRING). THE FAILURE MILEAGE WAS 9,368 AND THE CURRENT MILEAGE WAS 175,000. UPDATED 8/21/12 *CN THE CONSUMER STATED THE HIGH PRESSURE OIL PUMP, FRONT END SEALS, END RINGS, FUEL INJECTORS, TURBO CHARGER, HEAD GASKETS AND EGR VALVE WERE REPALCED. THE TRANSMISSION WAS SLIPPIING WHEN THE VEHICLE WAS PUT IN REVERSE. THE ABS LIGHT ILLUMINATED.

Jul 16, 2012

STEERING,VEHICLE SPEED CONTROL,ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

I PURCHASED THE TRUCK USED FROM A PRIVATE DEALER IN AUG 2011 WITH 66,000MI. ON IT! FROM THE DEALER THIS ISSUE STARTED. IT HAS HAPPENED AT LEAST 2 DZ TIMES NOW AND FORD REFUSES TO ACCEPT THE ISSUE AS A FORD ISSUE! THEY TELL ME ITS THE TIRE PRESSURE AND I HAVE HAD IT TO THEM 3 TIMES TO FIX THIS ISSUE, THEY HAVE RE INFLATED MY TIRE PRESSURE TO " FACTORY RECOMMENDED PRESSURE" AND WITHIN 5 MILES ITS SHAKING SO VIOLENTLY I HAVE TO PULL OVER AND START AGAIN, THIS WILL CAUSE A DEATH EVENTUALLY!! I WILL NOT LET MY WIFE DRIVE THIS TRUCK AND THAT IS WHAT IT WAS BOUGHT FOR, A SAFE FAMILY VEHICLE. *TR

Mar 05, 2012

ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM

1 complaint

WHILE APPROACHING A STOP LIGHT AFTER DOING 60MPH ON THE HIGHWAY, VEHICLE SHUT ITSELF DOWN CAUSING LOSS OF CONTROL AND BRAKING SYSTEM. I WAS ABLE TO BRING VEHICLE TO SAFE AND COMPLETE STOP WHICH CAUSED A TRAFFIC JAM. *KB

Nov 30, 2011

STEERING,SERVICE BRAKES, HYDRAULIC

1 complaint

LOST FAN BELT TRAVELING 65/MPH THEREBY LOST ALL STEERING AND BRAKES .WAS ON SECONDARY HIGHWAY COASTED INTO A SMALL TOWN AND USED MY EMERGENCY BRAKE TO STOP. MY WIFE PANICKED JUST LUCKY I WAS DRIVING ,HAVING BEEN A MECHANIC FOR 35 YEARS HAD ENOUGH SENSE TO NOT PANIC AND USE EMERGENCY BRAKE TO STOP. *TR

Oct 03, 2011

STEERING,SUSPENSION,ENGINE AND ENGINE COOLING

1 complaint

2005 FORD F-350. LETTER ON BEHALF OF REGARDING HER CONCERNS WITH FORD MOTOR COMPANY BEING HELD ACCOUNTABLE FOR THEIR DEFECTIVE 6.0 LITER DIESEL ENGINE VEHICLE; REPLY ATTN: KIM CORDELL/BLOUNTVILLE, TN OFFICE *TGW THE CONSUMER STATED THE TURBO WAS REPLACED FOUR TIMES. SHE ALSO STATED FORD HAS IGNORED THE FRONT END AND STEERING PROBLEMS AS WELL. *JB

Sep 13, 2011

VEHICLE SPEED CONTROL

1 complaint

TL*THE CONTACT OWNS A 2005 FORD F-350. WHILE STOPPED WITH HER FOOT ON THE BRAKE PEDAL THE VEHICLE ATTEMPTED TO SURGE FORWARD. THE RPMS INCREASED EXCESSIVELY AND SHE HAD TO APPLY EXTREME PRESSURE TO THE BRAKE PEDAL IN ORDER TO STOP THE VEHICLE FROM SURGING FORWARD. THE FAILURE ALSO OCCURRED INTERMITTENTLY WHILE DRIVING THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE SHE WAS INFORMED THAT THE EGR COOLER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 39,000.

Oct 13, 2010

FUEL SYSTEM, DIESEL,ELECTRICAL SYSTEM

1 complaint

WHILE ON I-95, MY 2005 F-350 SUPER-DUTY SPUTTER AND LOST POWER. THE TRUCK WENT FROM 60MPH WITH FLOW OF TRAFFIC TO 40MPH IN SECONDS. MAKING EVASIVE MEASURE FROM GETTING TAG FROM BEHIND, I WAS FORCED TO THE SHOULDER OF THE ROAD WHICH WAS TAKING UP BY SNOW. THE TRUCK CRAWLED HALF ON SHOULDER AND HALF IN THE RIGHT LANE WHILE CARS MADE THERE EVASIVE ACTION IN ORDER TO MISS ME. AFTER GETTING TO A PLACE TO PULL OFF THE HIGHWAY IT TOOK ABOUT 5-10MIN FOR IT TO CLEAR UP. THE DEALER INFORMED ME THAT THE FUEL TANK WAS DETERIORATING AND PROCEEDED TO ASK ME ABOUT MY FUEL AND WERE I GET IT, BECAUSE IT MUST BE CONTAMINATED. I ALSO OWN THREE OTHER DIESEL TRUCKS A 1995, 1996 AND 2000 AND THEY ALL RUN ON THE SAME FUEL FROM THE SAME GAS STATION. BUT YET ALL THESE TANKS ARE FIND. THE DEALER WANTS TO REPLACE THIS TANK AT MY COST WITH A NEW ONE. AFTER READING ALL THE COMPLAINTS ON OTHER WEB SITES, THIS PROBLEM WILL UNMASK IT SELF AGAIN DOWN THE ROAD. AT THIS TIME I WILL PROBABLY BRING THE TRUCK HOME UNTIL I CAN COME UP WITH A SOLUTION. *TR

Dec 23, 2008

SUSPENSION,EQUIPMENT

1 complaint

ON JULY 4, 2005, I PURCHASED A 2005 FORD F350 SUPER DUTY LARIAT WITH LONG BED AND DUAL WHEELS AND 4WD AT EL CAJON FORD. FROM THE BEGINNING, THE TRUCK EXPERIENCED SEVERE FRONT-END VIBRATION WHEN I REACHED ABOUT 60 MPH. IT CONTINUED UNTIL I GOT TO ABOUT 80 MPH. I COMPLAINED ABOUT THIS PROBLEM FROM THE FIRST VISIT FOR SERVICE AT DOWNEY FORD. AFTER A FEW VISITS FOR DIAGNOSTICS, DOWNEY FORD INSTALLED A "DAMPENER" ON THE FRONT END. IT MADE THE PROBLEM BETTER, BUT IT DID NOT COMPLETELY CURE THE DEFECT. I EVENTUALLY BOUGHT A LANCE CAMPER, WHICH WAS ON THE TRUCK FOR OVER A YEAR. WHILE THE TRUCK HAD THE 3000 LB CAMPER ON IT, THE VIBRATION WENT AWAY ON THE STRAIGHTAWAY, BUT WAS HORRIBLY DANGEROUS ON THE CURVES. FOR EXAMPLE, ONE SUCH CURVE IS THE 605 SB TO THE 405 SB IN LONG BEACH. I ALMOST LOST CONTROL OF THE VEHICLE/CAMPER ON THIS CURVE UNLESS I ALMOST STOPPED. I REMOVED THE CAMPER ABOUT A YEAR AGO AND THE PROBLEM WITH THE TRUCK IS WORSE. IT NOW WILL VIBRATE UNCONTROLLABLY AT 40-50 MPH. I REPORTED THIS VIBRATION PROBLEM EVERY TIME I WENT TO THE DEALER FOR SERVICE. THEY ALWAYS SAID THEY DID ALL THEY COULD WITH THE DAMPENER. I TOOK THE TRUCK TO EL CAJON FORD ABOUT 3-4 WEEKS AGO. NOW THAT IT IS OUT OF WARRANTY, FORD NOW SAYS IT CAN FIX THE PROBLEM, BUT IT HAS DAMAGE THE FRONT STEERING MECHANISM. THE SERVICE WRITER SAID IN A VOICE MAIL THAT DOWNEY PUT ON A DAMPER THAT WAS TOO SMALL FOR MY TRUCK. I DEMANDED THEY FIX IT FREE AND THEY REFUSE. I WANT MY TRUCK FIXED. THIS IS A DESIGN DEFECT, SINCE IT HAS EXISTED FROM DAY 1. I HAVE READ ON SEVERAL WEBSITES THAT THIS IS A COMMON PROBLEM THAT EXISTED WELL BEFORE 2005, BUT FORD HAS IGNORED THE SAFETY ISSUES. A HIGH PROBABILITY OF AN ACCIDENT EXISTS WHEN YOUR TRUCK IS VIBRATING AND BOUNCING ACROSS LANES AND YOU CANNOT STEP ON THE BRAKE OR MAKE IT WORSE! THANK YOU, ANNETTE GILLIAM *TR

Nov 15, 2008

AIR BAGS,STRUCTURE

1 complaint

THIS IS A DESIGN ISSUE. THE 2005 FORD F350 HAS A LARGE PART OF ITS REAR BUMPERS' HORIZONTAL SURFACE REMOVED. THE BUMPER IS THEN COVERED IN A HARD PLASTIC. I STEPPED OFF THE DECK OF MY TRUCK ONTO THE BUMPER AND THE PLASTIC SURFACE GAVE WAY. I ALMOST BROKE MY ANKLE AND LOST MY BALANCE , NOT BECAUSE THE PLASTIC BROKE THROUGH , IT JUST HAD WAY TOO MUCH FLEX IN IT. I'VE TRIED TO DEAL WITH FORD CO REGARDING THIS BUT AS YOU PROBABLY KNOW ,THEY WANT ZERO TO DO WITH THE RETAIL / POST WHOLESALE APPARATUS. I WAS TOLD TO TALK TO THE DEALER. I WOULD HAVE MORE COMPETENCE AND HONEST FEEDBACK FROM MY DOG. *TR

Mar 07, 2008

EQUIPMENT,EQUIPMENT ADAPTIVE/MOBILITY

1 complaint

TL* - THE CONTACT HAS A AEVIT BY EMC. THE CONTACT STATED THAT THIS EQUIPMENT WAS USED TO HELP WITH STEERING, BRAKING, AND ACCELERATION. THE CONTACT WAS JUST GOING DOWN THE ROAD WHEN ALL OF A SUDDEN THE AEVIT SYSTEM MADE A HARD LEFT AND SENT THE VEHICLE INTO A DITCH. THE CONTACT HAD TO GET SEVEN STITCHES ON HIS THE RIGHT SIDE OF FOREHEAD. A POLICE REPORT WAS TAKEN. THE WEATHER THAT DAY WAS COLD, BUT CLEAR. HE WAS DRIVING APPROXIMATELY 25 - 30 MPH. THERE WAS APPROXIMATELY $7,000 WORTH OF DAMAGE DONE TO THE VEHICLE. THE VEHICLE HAS BEEN REPAIRED, BUT HE HAS NOT DRIVEN THE VEHICLE SINCE. THE CONTACT NO LONGER HAD THE VEHICLE. *AK

Mar 09, 2007

2005 FORD F-350 Problems & Complaints

Complaints by Component

Frequently Asked Questions

How many problems does the 2005 FORD F-350 have?

What are the most common problems with 2005 FORD F-350?

Where does this 2005 FORD F-350 problem data come from?

Other Years - FORD F-350

Other FORD Models

Similar Brands