How many problems does the 2006 FORD F-350 have?

The 2006 FORD F-350 currently has 145 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2006 FORD F-350?

The most common problems reported for the 2006 FORD F-350 are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2006 FORD F-350 problem data come from?

All problem and complaint data for the 2006 FORD F-350 comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.

2006 FORD F-350 Problems

STEERING,SUSPENSION

23 complaints

The contact owns a 2006 Ford F-350. The contact stated that while driving approximately 45 MPH, the front passenger wheel drove over a small dip in the roadway and the vehicle started to shimmy. The contact stated that the vehicle was difficult to steer. The contact continued driving at a slower speed to allow the shimmy to self-correct. There was no warning illuminated. The contact had taken the vehicle to an independent mechanic to be diagnosed; however, no cause for the failure was found and the failure was not duplicated. The vehicle was not repaired. The mechanic checked for recalls related to the failure and advised the contact that the manufacturer had issued a recall for the failure (09L02) for severe steering wheel and front wheel vibrations. The manufacturer was not informed of the failure. The failure mileage was approximately 265,000.

Jul 21, 2025

My truck experiences what I have learned is called the death wobble. The condition occurs intermittently but usually at speeds above 50mph and seems to be initiated by hitting any small bump. The whole front end shakes violently like the tires have been half filled with lead causing them to rotate wildly out of round. The truck actually bounces up and down rapidly and the steering wheel shakes violently creating a very unsafe driving circumstance. My research into this issue uncovered that this is a well-known condition that has been reported multiple times by many different Ford truck owners and that it occurs on Ford trucks of various year make and model. I also am aware of Fords service letter 09L02 advising owners to maintain proper air pressure to combat the issue. It is my opinion that Fords efforts to address this issue are woefully inadequate and the NHTSA has allowed this manufacturer to produce and provide an unsafe vehicle to the public for way to long. This is a hazardous condition that needs to be properly addressed.

Jun 02, 2021

I WAS RIDING DOWN HWY55 AT ABOUT 65 TO 70 MPH AND TRUCK STARTS TO WOBBLE AND BOUNCE UNCONTROLLABLY. THE TRUCK BOUNCED TO THE OTHER SIDE OF THE ROAD. I THOUGHT I HAD A FLAT. AFTER GATHERING MYSELF I GOT OUT TO CHECK TRUCK AND THERE WAS NO FLATS AND ALL LUGS WAS THERE. I THOUGHT MAYBE I RAN OVER SOMETHING BUT ABOUT 12 MILES DOWN THE TRUCKS DOES IT AGAIN. BUT THERE ARE MANY CARS BEHIND AND ON THE SIDE OF ME. CARS AND TRUCKS ARE GOING DOWN THE OF ROAD TO GET OUT OF WAY. THIS IS SO A VERY FRIGHTEN AND HORRIBLE EXPERIENCE WHEN YOU ARE NOT PREPARED OR AWARE OF ABOUT THIS TRUCK. FORD TO BE ON OF THE TOP TRUCK MANUFACTURE IT GREATLY SADDEN ME TO KNOW THAT YOU ARE VISUALLY AWARE OF THE TRUCKS DEATHLY DEFECT FOR OVER 15 YEARS. YOU HAVE NOT MADE AN EFFORT TO PROVIDE A SAFE DURABLE PRODUCT TO PROTECT YOUR ROYAL CUSTOMERS OR YOURSELVES. TECHNOLOGY HAS AFFORDED MANY SEEN APPLICATION TO DO SO. YET YOU HAVE IGNORE WHAT IS YOUR COMPANY FUTURE.

Sep 28, 2020

DEATH WOBBLE, THE TRUCK SHAKES VIOLENTLY WHEN I DRIVE ON THE FREEWAY SINCE DAY ONE WHEN I BOUGHT IT . THE DEALER WON'T FIX IT THAT , THERE'S NOTHING WRONG WITH IT .AND THE DEALER SAYS TO REMOVE AIR FROM THE TIRES AND IT SHOULD STOP THE SHAKING .

Jan 20, 2020

FORD F-350 2006 OSCILLATION I HAVE FILED A PREVIOUS COMPLAINT BEFORE RE THE VIOLENT OSCILLATION THAT HAPPENS WITH OUR FORD F-350 TRUCK. WE HAVE HAD MORE EVENTS AT SLOWER SPEEDS AND THE SHAKING IS ALMOST UNMANAGEABLE NOW. WEDNESDAY MAY 11 APPROX 1PM EXITING THE BOURNE BRIDGE MA. I WAS DRIVING AT APPROX 40MPH AND EXITING THE BRIDGE. THERE WAS A ROUGH CONSTRUCTION PATCH ON THE ROAD RIGHT WHERE THE ROAD CONNECTS TO THE BRIDGE. AS I HIT THE ROUGH PATCH, THE OSCILLATION BEGAN AND THE TRUCK SHOOK UNCONTROLLABLY APPROACHING THE ROTARY. THERE WAS A LOT OF TRAFFIC AND CARS IN THE LANE BESIDE ME THAT COULD HAVE BEEN DAMAGED. MAY 20, 2016 AT APPROX 5PM. MY HUSBAND WAS DRIVING WEST ON HIGHWAY ROUTE 6, CAPE COD MA AT APPROX 55MPH. AS HE PASSED EXIT 6, HE HIT A ROUGH PATCH AND THE TRUCK BEGAN OSCILLATING VIOLENTLY. HE WAS UNABLE TO CONTROL IT AND SWERVED IN BOTH LANES OF THE WESTERLY 2-LANE HIGHWAY ALSO RUBBING AGAINST THE CURB. LUCKILY THE TRAFFIC STOPPED WHEN SEEING HIS TRUCK OUT OF CONTROL AND NO ONE WAS HURT OTHER THAN MY HUSBAND BEING TOTALLY SHAKEN. THE TIRES HAVE BEEN INFLATED AS RECOMMENDED BY FORD WHEN THE SENT A LETTER RE THIS DEFECT. THIS TRUCK IS DANGEROUS, NOT ONLY TO US BUT OTHERS WHO ARE ON THE ROAD. I HAVE CONTACTED THE PLYMOUTH FORD DEALER WHERE THE TRUCK WAS PURCHASED, FORD CUSTOMER SERVICE AND FORD HEAD OFFICE. EVEN THOUGH THEY ACKNOWLEDGE THE TRUCKS ARE DEFECTIVE, THEY SAY THEY ARE NOT RESPONSIBLE FOR REPAIRING THEM. OUR TRUCK IS OSCILLATING REALLY BADLY AND IS DANGEROUS TO DRIVE. THIS SHOULD BE A RECALL, NOT ONLY FOR THOSE OF US DRIVING THESE DEFECTIVE FORD F-350 2006 TRUCKS, BUT FOR THE OTHER INNOCENT LIVES ON THE ROAD.

May 26, 2016

+ 18 more complaints for this component

SUSPENSION

17 complaints

8 years ago was crossing RR tracks and vehicle started violently shaking had to slow to 10mph for it to stop. Checked found nothing wrong finished drive home. Took to Ford dealership and they said some tricks shake when tire pressure is wrong and didn't find anything wrong with vehicle. Truck did this once more and after that when I approach RR tracks I slow to 5- 10 mph to keep it from happening. Took it back to Ford 1 time and again they spoke about tire pressure but tire pressure was fine. In the last 2 weeks anytime I hit a bump the truck violently shakes I took to a mechanic shop and they said something was wrong with front end but not sure what. I called Ford and they said to bring it in. We will see what happens because this truck has done this off and on for the last 8 years, but now it does it all the time. It has been shaking so violently I wouldn't be surprised if other damages have happened from it.

Feb 16, 2022

TRUCK VIBRATES UNCONTROLLABLY AFTER HITTING BUMPS OR UNEVEN PAVEMENT AT HIGHWAY SPEEDS I REPLACE THE BRAKES THREE TIMES AND THAT DIDN'T FIX IT THIS HAS BEEN GOING ON SINCE IT HIT ABOUT 60K MILES. IT NOW HAS 108K I CAN NOT TRUST THIS TRUCK ANYMORE.

Mar 11, 2021

ON 2/28/21 AND 3/6/21 WHILE DRIVING AT HIGHWAY SPEED, I EXPERIENCED TWO SEPARATE VIOLENT SHAKING EVENTS OF THE FRONT SUSPENSION AND STEERING. BOTH EVENTS OCCURED AT APPROXIMATELY 70MPH UPON CROSSING PAVEMENT JOINTS. THE SHAKING IS SO VIOLENT YOU LOSE THE ABILITY TO CONTROL THE VEHICLE AND JUST HOPE IT DOESN'T CAUSE A WRECK. THE SHAKING WILL NOT STOP UNTIL SPEED IS REDUCED TO APPROXIMATELY 20MPH, WHICH IN ITSELF IS DANGEROUS ON AN INTERSTATE HIGHWAY. A PASSENGER IN MY TRUCK DURING FIRST INCIDENT SAID HE THOUGHT I HAD HIT A LOAD OF PIPES IN THE ROAD. DURING THE SECOND EVENT, NEARBY MOTORISTS LOOKED AT ME LIKE MY TRUCK WAS FALLING APART. I AM VERY UPSET THAT FORD AND NHTSA HAVE NOT ISSUED A RECALL. THIS PROBLEM STARTED WHEN VEHICLE WAS BRAND NEW. FIRST DEALER TOLD ME THERE WAS NOTHING THEY COULD DO. A SECOND DEALER TIGHTENED VARIOUS FASTENERS ON FRONT SUSPENSION AND MADE STEERING BOX VERY TIGHT. I WAS ALSO GIVEN NEW ALIGNMENT SPECS (WHICH I GAVE TO TIRE INSTALLER), AND ADVISED INFLATING TIRES TO MUCH HIGHER PRESSURE THAN TRUCK WAS DELIVERED NEW WITH. IT IS UNWORKABLE BECAUSE IT RESULTS IN BRUTAL RIDE IF TRUCK IS OPERATED WITHOUT PAYLOAD. I BELIEVE THESE EVENTS ARE CAUSED BY UNDAMPED RESONANCE IN THE FRONT SUSPENSION. IT FEELS LIKE THE WHEELS ARE ALTERNATELY POUNDING UP AND DOWN, LEFT AND RIGHT SIDE. THE STEERING WHEEL OSCILLATES SO HARD YOU CAN'T HOLD ON.

Mar 09, 2021

THE FRONT SUSPENSION WOBBLES VERY BAD WHEN GOING 40-60 MILES OVER A SMALL UNEVEN PAVEMENT. JUST REPLACED THE TIRES AND GOT AN ALIGNMENT. STILL HAVING THE SAME PROBLEM, I'M NOT ABLE TO DRIVE MY TRUCK CAUSE IT WOBBLES SO BAD THAT I HAVE TO COMPLETELY STOP FOR THE WOBBLING TO STOP. I PURCHASED MY TRUCK NEW AND NOW HAS 92K AND HAD NEVER BEEN IN AN ACCIDENT OR AFTER MARKET TIRES OR PARTS. I HAVE ALWAYS KEPT IT WITH GENUINE PARTS DON'T KNOW THE PROBLEM AND NEED HELP.

Apr 24, 2019

TL* THE CONTACT OWNS A 2006 FORD F-350. WHILE DRIVING 65 MPH OVER BUMPS IN THE ROAD, THE VEHICLE SHOOK VIOLENTLY. THE DEALER DIAGNOSED THAT THE FRONT AXLE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED BECAUSE THE REMEDY WAS NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

Jun 13, 2016

+ 12 more complaints for this component

STEERING

17 complaints

TRUCK HAS A STEERING PROBLEM.MOST OF THE TIME TRUCK TRAVELS STRAIT.SOME TIMES AFTER MAKING A TURN RIGHT OR LEFT THE TRUCK CONTINUES TRAVEL IN THAT DIRECTION! I HAVE TO YANG HARD ON THE STEERING WHEEL BACK IN OPPOSITE DIRRECTION TO GET TRUCK BACK IN ITS LANE!ALSO SOMETIMES THE TRUCK OUT OF THE CLEAR BLUE TRUCK TAKE OFF TO THE RIGHT OR LEFT AN I HAVE T PULL THE WHEEL IN OPPOSITE DIRECTION TO GET TRUCK BACK IN IT'S LANE!OTHER TIMES GOING THAN THE ROAD THE TRUCK HITS A BUMP IN THE ROAD AN TRUCK WILL EITHER GO RIGHT OR LEFT AN STEERING WHEEL HAS TO BE PULL THE OPPOSITE DIRECTION TO GET IT BACK IN IT'S LANE! I NOTICE THIS SAME PROBLEM HAS BEEN REPORTED BEFORE AN NO ONE HAS BEEN ABLE TO FIX IT! MECHANICS SAY IT'S THE STEERING PUMP OR STEERING BOX WHICH HAS NOT CORRECTED ANY BODY'S TRUCK THAT THAT HAS BOTH THESE PARTS REPLACE! THIS CAN CAUSE A MAJOR ACCIDENT FORD SHOULD FIX THIS PROBLEM

Sep 25, 2019

STEERING WOBBLE AND SHAKES. THIS HAS BEEN GETTING WORSE AS TIME GOES ON. ANYTIME I HIT A BUMP ON THE FREEWAY MY TRUCK STARTS TO VIOLENTLY SHAKE AND WOBBLE. IT IS EVEN WORSE ON A ROAD CURVE. IT IS VERY DANGEROUS TO DRIVING ON THE FREEWAY IN THE MOUNTAINS. I FEW TIMES I ALMOST LOST CONTROL. THE SHAKE DOES NOT GO AWAY UNTIL I SLOW DOWN BELOW 40MPH WHICH CAUSES ANOTHER DANGEROUS SITUATION WHILE ON THE FREEWAY. I HAVE CHANGED TIRES, CHECKED PRESSURE AND ROTATED TIRES. ALSO, I REPLACED STEERING DAMPENER. NOTHING HAS WORKED TO DIMINISH THE SHAKE. I ALSO HAD THE 4 WHEEL ALIGNMENT CHECKED AND THE SHOP SHOWED ME THAT IT WAS CORRECT. THEY CHECKED EVERYTHING AND COULD NOT FIND ANYTHING THAT WAS WORN OUT AND NEEDED CHANGING. I WAS TOLD NO REPAIRS NEEDED. THIS IS A VERY DANGEROUS SITUATION AND NEEDS TO BE CORRECTED BEFORE BODIES START PILING UP. *TR

Oct 29, 2014

DRIVING VEHICLE WITH FIFTH WHEEL 31 FT CAMPER IN TOW VEHICLE LURCHED TO THE LEFT AND ATTEMPTS TO CORRECT FOUND GREAT RESISTANCE IN STEERING RESPONSE. ON SEVERAL OCCASIONS SINCE AND AT NO SPECIFIC SPEED THE VEHICLE WILL LURCH TO THE LEFT OR RIGHT OR SHIMMY TO THE POINT THAT STEERING BECOMES ALMOST UNRESPONSIVE. I HAD THE VEHICLE CHECKED AND WAS ADVISED NOTHING WAS IN NEED OF REPLACEMENT. THEN I RECEIVED A LETTER FROM FORD MOTOR CO DESCRIBING THE EXACT STEERING SITUATION THAT I AM EXPERIENCING ALONG WITH RECOMMENDATIONS TO KEEP TIRES INFLATED PROPERLY, WHICH I HAVE AND CONTINUE TO HAVE CORRECT. I CONTACTED FORD TO VOICE MY CONCERN AND WAS ADVISED THIS IS "JUST A NORMAL QUALITY OF A SOLID FRONT AXEL 4 WHEEL DRIVE TRUCK". I USE THIS VEHICLE TO PULL A CAMPER AND WHEN THIS "SEVERE VIBRATION AND OSCILLATION" OCCURS IT CAUSES THE TRUCK/TRAILER TO LURCH SO FAR AS TO CAUSE IT TO SHIFT LANES. THIS PROBLEM OCCURS AT ALL SPEEDS, EVEN HIGHWAY SPEEDS OF 70MPH. I WAS ALSO TOLD THAT THE LETTER WAS ONLY A "NOTIFICATION OF THE SITUATION AND HOW TO AVOID" AND NOT A RECALL. FURTHERMORE, FORD ADVISED THAT I TAKE THE VEHICLE IN TO A FORD DEALER AT MY COST TO ENSURE THAT THIS WAS THE CAUSE OF THE PROBLEM. THIS SITUATION IS SEVERE ENOUGH THAT IT COULD AND PERHAPS HAS BEEN THE CAUSE OF TRAFFIC ACCIDENTS. HOW LONG WILL THIS BE ALLOWED TO GO ON BEFORE A RECALL IS ISSUED? HAVING IDENTIFIED A VEHICLE STEERING PROBLEM, THAT IN MY OPINION COULD BE LIFE THREATENING, SHOULD BE SUFFICIENT CAUSE FOR A RECALL TO BE ISSUED. *TR

Jan 16, 2014

STOPPED AT A TRAFFIC LIGHT AT A THREE WAY INTERSECTION. WHEN LIGHT CHANGED PROCEEDED THROUGH THE INTERSECTION TO THE LEFT SPEED WAS BETWEEN 10-15 MPH HALF WAY THROUGH THE INTERSECTION WHEN THE STEERING BOX FAILED. LOST ALL STEERING AND COLLIDED WITH TELEPHONE POLE OPPOSITE THE INTERSECTION.THERE WAS NO PRIOR WARNING OR PREEMPTIVE SIGNS OF EQUIPPED FAILURE. THE VEHICLE WAS IN PERFECT WORKING ORDER AT THE TIME OF FAILURE. THE COLLISION CENTER WHO DID THE ESTIMATE ON THE TRUCK STATED HE HAD NEVER SEEN A STEERING BOX FAIL THE WAY THIS ONE DID THE PINION GEAR IN SIDE EXPLODED! *TR

Feb 24, 2012

Crash: 1

TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THAT HE DROVE OVER A ROAD BUMP AT 30 MPH AND THE VEHICLE BEGAN TO VIBRATE UNCONTROLLABLY. THE CONTACT WAS UNABLE TO CONTROL THE VEHICLE AS IT STEERED INTO THE ONCOMING LANE OF TRAFFIC. THE CONTACT RELEASED THE ACCELERATOR PEDAL AND REGAINED CONTROL AS THE VEHICLE DECELERATED. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 60,500. UPDATED 1/20/12 *CN UPDATED 02/01/12

Dec 08, 2011

+ 12 more complaints for this component

ENGINE AND ENGINE COOLING

13 complaints

TL* THE CONTACT OWNS A 2006 FORD F-350. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT STATED THAT EXHAUST FUMES WERE EMITTING FROM THE EXHAUST MANIFOLD IN FRONT OF THE VEHICLE. IN ADDITION, THE CONTACT STATED THAT THERE WERE EXHAUST FUMES IN THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 25,000.

Feb 26, 2015

TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THAT THE VEHICLE WAS STARTED AND WHILE ACCELERATING, BLUE SMOKE WAS SEEN COMING FROM THE VEHICLE AND THE TACHOMETER INDICATED THAT THE VEHICLE HAD NOT RESPONDED. THERE WAS A LOUD ROAR FROM THE ENGINE THAT WOULD BECOME PROGRESSIVELY LOUDER AS THE ACCELERATOR WAS DEPRESSED. THE CONTACT WAS ABLE TO ACCELERATE AFTER SEVERAL MINUTES HOWEVER, THE VEHICLE DID NOT EXHIBIT ENOUGH POWER TO ACCELERATE UPHILL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS AND THE CONTACT WAS ADVISED THAT THE HEAD GASKETS, TURBO AND TWO FUEL INJECTORS WOULD NEED REPLACING. IN ADDITION, THE EGR WOULD NEED TO BE BYPASSED WITH A KIT IN ORDER TO CORRECT THE ENGINE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE BUT OFFERED LITTLE ASSISTANCE. THE FAILURE AND THE CURRENT MILEAGES WERE 227,000. UPDATED 7/16/12 *CN THE CONSUMER STATED THE PROBLEM WAS WITH THE EGR VALVE, WHICH CLOGGED THE EXHAUST AND TURBO FILTERS, WHICH CAUSE CARBON BUILD-UP. UPDATED 07/24/12

Jun 21, 2012

TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT WAS DRIVING 60 MPH WHEN THE VEHICLE EXHIBITED AN ABNORMALLY LOUD NOISE AND STALLED. THE CONTACT MENTIONED THAT THE FAILURE OCCURRED ONCE PRIOR. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE TURBO CHARGER WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 65,000 AND THE CURRENT MILEAGE WAS 85,000.

Jan 19, 2012

THE ABOVE MENTIONED TRUCK WHICH HAS 11,750 MILES ON IT. SINCE IT WAS PURCHASED AT THE END OF 2005, THE TURBOCHARGER HAS BEEN REPLACED FIVE TIMES OR AT APPROXIMATELY 2000 MILE INTERVALS. THE VEHICLE IS WELL MAINTAINED WITH OIL AND FILTER CHANGES MORE FREQUENT THAN FORD RECOMMENDS. DUE TO A PREVIOUS COMPLAINT REGARDING FAULTY TURBOS, FORD EXTENDED MY WARRANTY UNTIL 2011 THROUGH AN OASIS SERVICE CONTRACT. FORD ACKNOWLEDGED PROBLEMS WITH FAULTY TURBOS THROUGH THE ISSUANCE OF SIX OR MORE TECHNICAL SERVICE BULLETINS. A FAULTY TURBO CAUSES THE TRUCK TO RUN POORLY AND FAIL CONNECTICUT EMISSIONS TESTS AND RISKS FURTHER ENGINE DAMAGE. I HAVE CONTACTED FORD CUSTOMER SERVICE. I HAD SENT THEM REPAIR RECORDS, PHOTOS AND DOCUMENTATION. THEY NEVER RESPONDED IN WRITING, BUT PHONED AND SAID THERE WAS NOTHING FURTHER THAT THEY WOULD DO. IT IS APPARENT THAT THERE IS AN ENGINEERING OR DESIGN FLAW ASSOCIATED WITH THE TURBOS. FORD HAS REPLACED EACH TURBO WITH THE SAME TYPE AND HAS FAILED TO CORRECT THE ROOT CAUSE OF THE FAILURES. I'M NOT REQUESTING REPLACEMENT OF THE VEHICLE, NOR MONETARY COMPENSATION ALTHOUGH THIS PROBLEM HAS CAUSED CONSIDERABLE INCONVENIENCE AND LOSS OF TIME. I AM REQUESTING, THAT IF FORD CANNOT REPAIR THIS PROBLEM, ONCE-AND-FOR-ALL, THAT THEY EXTEND THE WARRANTY FOR THE LIFE OR THE TRUCK OR AT LEAST FOR AS LONG AS I OWN THE TRUCK. *TR

Jan 04, 2012

TL*THE CONTACT OWNS A 2006 FORD F350. THE CONTACT STATED WHILE ATTEMPTING TO REVERSE, THE VEHICLE LOST POWER AND RELEASED SMOKE. THE VEHICLE WAS TOWED TO DEALER WHO PERFORMED A DIAGNOSTIC THAT LOCATED THE FAILURE AT THE ENGINE EXHAUST EGR VALVE. THE MANUFACTURER DENIED ASSISTANCE WITH THE REPAIR. THE EGR VALVE WAS REPLACED. THE FAILURE MILEAGE WAS 113,048 AND THE CURRENT MILEAGE WAS 114,232. UPDATED 02/03/12*LJ UPDATED 02/08/12

Nov 14, 2011

+ 8 more complaints for this component

ENGINE

9 complaints

2006F-350 super duty 5.4engine,,had to be replaced two and a half years ago the Ford dealer at cirroca of York,,told me that the new motor was improved that the new motors valve train was improved,,why wasn't it a recall,, if it would affect emissions and overall performance and reliability

Nov 19, 2025

ENGINE DIES WHILE DRIVING. DOES NOT DO IT ALL THE TIME. MAINLY WHEN ACCELERATING AND IF LET OFF GAS AND APPLY BRAKES.

Nov 22, 2017

TL* THE CONTACT OWNS A 2006 FORD F-350. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED LIQUID UNDER THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THERE WAS A DAMAGED HEAD GASKET THAT NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS UNKNOWN.

Mar 17, 2017

TL* THE CONTACT OWNS A 2006 FORD F-350. WHILE DRIVING APPROXIMATELY 60 MPH, THE EXHAUST PIPE SMOKED AND/OR STEAMED AND THE ENGINE OVERHEATED. THE CHECK TEMPERATURE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT FILLED THE ENGINE WITH WATER AND DROVE HOME. THE DEALER DIAGNOSED THAT THE EGR COOLER LEAKED; THEREFORE, THE EGR COOLER AND THE OIL COOLER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 84,000. THE MANUFACTURER WAS NOT NOTIFIED.

May 31, 2016

TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE VEHICLE STARTED TO EMIT WHITE SMOKE. THE VEHICLE TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE TURBO BOOSTER AND FUEL INJECTORS WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 112,000 AND THE CURRENT MILEAGE WAS 124,000.

Nov 19, 2013

+ 4 more complaints for this component

FUEL SYSTEM, DIESEL

9 complaints

The contact owns a 2006 Ford F-350. The contact stated that while the vehicle was parked, the contact noticed that fuel was leaking underneath the front driver's side of the vehicle. The vehicle was taken to an independent mechanic, who replaced the fuel pump block-off plate and plug. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 190,000.

May 13, 2024

THIS IS A 2006 FORD AMBULANCE THAT HAS BEEN HAVING ISSUE'S WITH THE FUEL SYSTEM OVER THE PAST TWO YEARS THE MOST RECENT WAS DURING A EMERGENCY RESPONSE WHEN THE AMBULANCE LOST POWER AND SHUT DOWN THE CREW WAS UNABLE TO COMPLETE THEIR RESPONSE TO THE EMERGENCY BECAUSE THE AMBULANCE WOULD NOT RESTART. THE AMBULANCE WAS TOWED TO THE FORD DEALERSHIP THEY REPORTED THE FUEL TANK WAS COMING APART ON THE INSIDE AND CLOGGING THE FUEL SYSTEM. WE CONTACTED FORD AND COMPLAIN OF ALL THE FUEL PROBLEM AND THE MOST RESENT THE FUEL TANK THE END RESULT WAS THEIR CLAIMING ITS NOT THEIR PROBLEM BUT OURS THE REPAIR EST IS OVER $7000.00 THIS AMBULANCE HAS SPENT MORE TIME IN THE SHOP THEN RESPONDING TO EMERGENCY CALLS AND HAS LEFT OUR CREWS SIT WHILE IN ROUTE OR ON THE SCENE OF MEDICAL EMERGENCY. THE FORD DEALER AND FORD MOTOR COMPANY REFUSE TO DO ANYTHING TO CORRECT THIS PROBLEM WE HAVE NEVER HAD THESE TYPE OF PROBLEMS WITH ANY AMBULANCE WE OWNED OVER THE PAST 15 YEARS AND A AMBULANCE BREAKING DOWN IN THE MIDDLE OF A EMERGENCY CALL IS A DANGEROUS ISSUE TO THE PATIENT AND CREW ...... *TR

Apr 02, 2012

LINER IN THE FUEL TANK CORRODED AND CLOGGED FUEL SYSTEM CAUSING FAILURE OF VEHICLE. *TR

Oct 19, 2011

TL* THE CONTACT OWNS A 2006 FORD F-350 DIESEL. THE CONTACT STATED THAT THE FUEL TANK WAS RUSTING DUE TO A FAULTY COATING ON THE INSIDE OF THE TANK. NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 61,000. THE VIN WAS UNAVAILABLE.

Sep 16, 2011

F-350 EGR COOLER WENT BAD AND SMOKED UP ENTIRE NEIGHBORHOOD. OTHER MOTORISTS COULD NOT SEE AS THE SMOKE EMITTED FROM MY F-350 WAS LIKE A VERY VERY THICK FOG. I CONTACTED FORD, WHO KNOWS ABOUT THE ONGOING AND EXTENSIVE PROBLEM, BUT THEY REFUSE TO DO ANYTHING BUT "DOCUMENT" THE PROBLEM AND WANT NHTSA TO MAKE IT A RECALL. APPARENTLY THERE ARE A LOT OF OTHER F-350 OWNERS WITH THE SAME PROBLEM. THIS IS VERY DANGEROUS. I'M NOT SURE IF THE FUMES THAT ARE EMITTED FROM THIS PROBLEM ARE SAFE EITHER. *TR

Nov 24, 2009

+ 4 more complaints for this component

AIR BAGS

5 complaints

The contact owns a 2006 Ford F-350. The contact stated that while driving at an undisclosed speed, the air bag warning light illuminated. A dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 120,000.

Apr 08, 2024

I WAS DRIVING ON NORTHBOUND FM 920 BETWEEN PEASTER AND POOLVILLE, TEXAS IN THE RAIN. BECAUSE OF THE RAIN, I WAS NOT DRIVING THE SPEED LIMIT OF 60 MPH, ONLY DRIVING APPROXIMATELY 50 MPH. THERE WERE TWO VEHICLES APPROACHING ME SOUTHBOUND ON FM 920. ONE OF THEM WAS PASSING A VEHICLE AND WAS DRIVING HEAD ON TO ME WHILE PASSING THE OTHER VEHICLE IN THE RAIN. I DID NOT WANT HER TO HIT ME SO I SWERVED TO MISS HER AND ENDED UP IN A DITCH AND HIT A TREE HEAD ON. THE AIRBAGS DID NOT DEPLOY. MY PICKUP WAS TOTALED. BOTH OF THE OTHER VEHICLES LEFT THE SCENE OF THE ACCIDENT. *TR

May 01, 2015

Crash: 1

Injuries: 1

TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE CONTACT CRASHED INTO A DEER AND THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS TOWED TO A DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 2,018. THE VIN WAS UNAVAILABLE.

Nov 05, 2014

Crash: 1

TL* THE CONTACT OWNS A 2006 FORD F-350 . THE CONTACT STATED THAT THE DRIVER WAS TRAVELING AN UNKNOWN SPEED AND CRASHED INTO AN EMBANKMENT. THE IMPACT CAUSED THE VEHICLE TO FLIP IN REVERSE AND LAND ON THE PASSENGER'S SIDE. THE AIR BAGS FAILED TO DEPLOY. THE DRIVER WAS KILLED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 161,000. *TR

Mar 03, 2014

Crash: 1

MY AIRBAG DID NOT DEPLOY DURING A COLLISION. MY 2006 F350 TRUCK WAS STRUCK (T-BONE STYLE) BY A 1998 TOYOTA ?CAMRY. THE TOYOTA WAS OUT OF CONTROL, SLIDING SIDEWAYS AT SPEED, AND SLAMMED INTO THE TRUCK. THE DRIVER'S DOOR OF THE TOYOTA WAS LEFT IMPALED UNDER MY FRONT BUMPER. DAMAGE TO THE FRONT END OF THE TRUCK WAS EXTENSIVE FROM THE AREA OF THE DRIVER'S SIDE WHEEL WELL THROUGH TO PAST THE CENTER LINE OF THE FRONT BUMPER. THE TRUCK IS JUST GOING IN TO THE BODY SHOP TODAY. INITIAL ESTIMATE OF DAMAGES IS $8700, ALTHOUGH THEY EXPECT TO FIND PROBLEMS WITH THE SUSPENSION/FRAME WHEN THEY GET UNDER THE VEHICLE. PERSONAL INJURIES: I HIT THE WHEEL, SUSTAINING BRUISING TO MY CHEST, R SHOULDER MUSCULAR INJURIES, AND WHIPLASH INJURY TO MY NECK. CHEST X-RAYS, SHOULDER X-RAYS, AND CT SCAN OF MY NECK SHOW NO BONE INJURIES, HOWEVER, AT 1 WEEK, I'M STILL TAKING QUITE A BIT OF PAIN AND MUSCLE RELAXING MEDS AND AM NOT ABLE TO COMPLETE MY DAILY WORK. I AM SELF EMPLOYED. *TR

Mar 03, 2010

Crash: 1

Injuries: 2

FUEL SYSTEM, GASOLINE

5 complaints

TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THE ENGINE OVERHEATED. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE EGR COOLER WAS FAULTY AND NEEDED TO BE REPLACED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE FAILURE WAS REPAIRED BUT THE PROBLEM PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000. PAM

Oct 30, 2014

MY FORD F350 TURBO DIESEL TRUCK WOULD NOT GO FASTER THAN APPROX. 25 MPH, COULD NOT GET ANY POWER. CAME TO A STOP LIGHT AND IT DIED AND WOULD NOT RESTART. HAD IT TOWED TO THE NEAREST FORD DEALER THINKING IT WOULD BE COVERED BY THE WARRANTY. THEY HAVE CHANGED THE FUEL INJECTOR CONTROL MODULE-NO FIX, THE FUEL PUMP AND FILTERS AND FOUND FOREIGN SUBSTANCE/CORROSION, PULLED THE FUEL TANK AND FOUND THE SOURCE OF THE CORROSION, DELAMINATING FUEL TANK. THE REPAIRS ARE UP TO $2500, THE FUEL TANK STILL TO COST $1300 TO REPLACE THE PART BUT STILL HAVE LABOR INVOLVED. ALSO THE FUEL INJECTORS, 5 OF THE 8 ARE EXHIBITING NO POWER AND VARIOUS OTHER FUEL FILTERS THAT THEY NAMED OFF WILL ALSO NEED TO BE CHANGED. THAT WILL COST ANOTHER SEVERAL THOUSAND. I HAVE CONTACTED FORD MANUFACTURER, CUSTOMER ASSISTANCE AND THEY STATE THEY WILL NOT PAY OR ASSIST ME IN THE COST EVEN THOUGH WE ARE ONLY 6 WEEKS OUT OF WARRANTY. THE TRUCK IS LIKE NEW, ONLY 66K MILES. THIS IS UNBELIEVABLE. I'VE NEVER EXPERIENCE SUCH A TRAUMATIC COSTLY PROBLEM IN AN AUTOMOBILE WITH ONLY 66K MILES. I STILL HAVE THE TRUCK AT THE DEALER AND CAN'T AFFORD TO PAY THE COST. *TR

Nov 02, 2011

TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THAT THE VEHICLE WOULD STALL AT ANY TIME WITHOUT WARNING. THE DEALER DIAGNOSED THAT THE FUEL TANK WAS RUSTED FROM THE INSIDE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 21,000 AND THE CURRENT MILEAGE WAS 24,500.

Sep 01, 2011

TL*THE CONTACT OWNS A 2006 FORD F-350. AFTER REFUELING THE VEHICLE HE ATTEMPTED TO START THE VEHICLE BUT IT WOULD NOT START. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE FUEL FILTER AND EGR VALVE WERE REPLACED. THE FAILURE CONTINUED TO RECUR EACH TIME HE ATTEMPTED TO START THE VEHICLE. THE VEHICLE WAS TAKEN BACK TO ANOTHER AUTHORIZED DEALER WHERE THEY WERE UNABLE TO DIAGNOSE THE FAILURE; THEREFORE, IT WAS NOT REPAIRED. HE ALSO STATED THAT WHITE SMOKES WAS COMING OUT OF THE EXHAUST PIPE. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 33,000.

Sep 08, 2010

TL* THE CONTACT OWNS A 2006 FORD F350. WHILE DRIVING AT A SPEED OF 60 MPH, THE ENGINE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO PULL OVER TO THE SHOULDER OF THE ROAD AND WAS ABLE TO RESTART THE VEHICLE WITHIN MINUTES. THE DEALER ADVISED THE FUEL TANK WAS DEFECTIVE AND WOULD NEED TO BE REPLACED. THIS WAS THE FIRST INCIDENT OF THE FAILURE. THE VEHICLE WAS LEFT IN POSSESSION OF THE DEALER FOR REPAIRS. THE FAILURE MILEAGE WAS 57,390 AND THE CURRENT MILEAGE WAS 57,400.

Apr 09, 2010

WHEELS

4 complaints

CRACKED POLISHED FORGED ALUM 20" WHEEL. ORIGINAL FORD EQUIPMENT. DID NOT HIT POT HOLE. DID NOT HIT ANYTHING! WHEEL IS CRACKED/SPLIT OPEN SPOKE TO SPOKE PARALLEL WITH TIRE BEAD. TIRE IS FINE. WHEEL IS OBVIOUSLY UNSAFE!

Apr 24, 2018

WHILE PARKED, A CRACK IN THE CIRCUMFERENCE OF THE DRIVERS SIDE ALUMINUM WHEEL WAS NOTICED. THE CRACK EXTENDS FROM SPOKE TO SPOKE ON THE 20" FACTORY FORD RIM. AFTER SOME RESEARCH ON THE INTERNET, I AM NOT THO ONLY ONE EXPERIENCING THIS SITUATION. IN MOST CASES SUCH AS MINE THE RIMS ARE CRACKING IN THE SAME PLACE AND IN MOST CASES THERE WAS NO DAMAGE NOTED TO THE WHEEL FROM POTHOLES OR IMPACTS, THE RIM IS DEFECTIVE AND CRACKING. I HAVE CONTACTED FORD AND THERE IS NO RECALL AT THIS POINT AND THE TRUCK IS NOT UNDER WARRANTY. HOWEVER THIS APPEARS TO BIG A HUGE SAFETY ISSUE, AS IF THE WHEEL WOULD CONTINUE TO CRACK, IT WOULD NOT HOLD AIR AN THE TIRE COULD GO FLAT IMMEDIATELY. I WOULD LIKE TO SEND A PICTURE OF THIS TO SHOW THE ISSUE. THERE ARE SEVERAL PICTURES ON THE INTERNET OF THE SAME WHEEL (5 SPOKE 20" ALUMINUM WHEEL 2006 F-350 TRUCKS). *TR

Oct 22, 2014

TL*THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT 50 MPH ON APRIL 10, 2008, THE LEFT DRIVER SIDE WHEEL VIBRATED VIOLENTLY. THE CONTACT HAD TO APPLY THE BRAKES TO SLOW THE VEHICLE DOWN. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE HE WAS INFORMED THAT THE RIMS WERE DEFECTIVE. THE RIMS AND TIRES WERE REPLACED AND A FRONT END ALIGNMENT WAS PERFORMED. THE FAILURE CONTINUED TO OCCUR. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE FAILURE MILEAGE WAS APPROXIMATELY 33,000. THE CURRENT MILEAGE WAS APPROXIMATELY 92,000.

May 26, 2010

I RECENTLY HAD A FLAT TIRE ON MY F-350 PICKUP. I NEEDED A SLEDGE HAMMER TO REMOVE THE TIRE! I CALLED THE DEALERSHIP WHERE I PURCHASED THE TRUCK, STILL UNDER WARRANTY, AND ASKED THEM ABOUT THE PROBLEM. THEY SAID, WE NORMALLY BEAT IT OFF THE TRUCK OURSELVES. SO I CONTACTED 2ND DEALERSHIP TO SEE HOW THEY HANDLED IT, THEY SAID THEY HAD TO BEAT THE RIM OFF THE TRUCK AS WELL. I CONTACTED FORD MOTOR COMPANY AND ASKED THEM IF I COULD BRING IT IN AND HAVE THEM BEAT THE TIRES AND RIMS OFF AND PUT SOME KIND OF ANTICEASE ON THE RIMS SO THEY WON'T RUST AND FREEZE ON THE TRUCK. I EXPLAINED TO HER THAT WHEN I WAS BEATING THE RIM OFF OF MY TRUCK I HAD CRAWLED OUT FROM UNDER THE TRUCK, IT FELL OFF THE JACK, IT CRACKED MY DRIVEWAY, AND I COULD HAVE BEEN KILLED. I TOLD FORD THIS SOUNDED LIKE A PRETTY DANGEROUS PROBLEM, WHAT WOULD THEY DO ABOUT THE COMPLAINT. THEY REFERRED ME TO THE MAINTENANCE GUIDE,TO ROTATE THE TIRES EVERY 5000 MILES. IT DOESN'T MENTION IT BEING DANGEROUS IF YOU DON'T ROTATE YOUR TIRES, JUST TO REDUCE TIRE WEAR ROTATE THE TIRES EVERY 5000 MILES. I THINK THIS TYPE OF PROBLEM SHOULD BE COVERED BY THE WARRANTY. NOT THE CUSTOMERS EXPENSE. I WAS TOLD TO TAKE THE TRUCK IN AND MAYBE I COULD WORK SOMETHING OUT WITH THE DEALERSHIP. I SHOULDN'T HAVE TO WORK IT OUT, BUMPER TO BUMPER SHOULD MEAN BUMPER TO BUMPER. NOT JUST WHAT THEY THINK SHOULD BE COVERED. APPARENTLY A LOT OF PEOPLE HAVE BEEN HAVING THIS PROBLEM. IF YOUR ON THE ROAD AND HAVE A FLAT IT COULD COST 2-300 DOLLARS TO BE TOWED IN,HAVE THE TIRES REMOVED TO CHANGE THE FLAT. SINCE THE RIM HAS TO BE BEAT OFF THE TRUCK. A WHEEL PULLER MIGHT WORK, SOMETHING YOU DON'T CARRY WITH YOU WHEN TRAVELING. THIS PUTS THE CONSUMER IN A VERY HAZARDOUS CONDITION. ALL FORD WAS INTERESTED IN WAS THE TIRE MIGHT NOT WEAR PROPERLY IF TIRES ARE NOT ROTATED. IT DOESN'T MENTION THE RIMS BEING FROZE UP BECAUSE I DID NOT ROTATE THEM. THERE IS ONLY 29,000 MILES ON MY VEHICLE. WHAT DO YOU THINK? CONCERNED CONSUMER. *TR

Apr 18, 2008

TIRES

4 complaints

HAD A CONTINENTAL CONTITRAC 275/70R18 BLOW OUT ON THE HIGHWAY WHILE TOWING. IT WAS A REAR DRIVE TIRE ON A 2006 F350 DIESEL. THE TIRE BLEW RIGHT APART, TREAD SEPARATED FROM THE TIRE, CAUSING ENTIRE LEFT SIDE BED DAMAGE, RESULTING IN OVER $3,000 OF DAMAGE TO THE TRUCK

Jan 03, 2018

TL*THE CONTACT OWNS A 2006 FORD F-350. THE VEHICLE HAS CONTINENTAL CONTITRAC TR BSW, SIZE LT275/70R18 125/122S TIRES. WHILE DRIVING 5 MPH, THE VEHICLE VIBRATED. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE PASSENGER SIDE REAR TIRE WAS FLAT. THE FACE OF THE TIRE DETACHED AND HE NOTICED PREMATURE WEAR ON ALL FOUR TIRES. AS OF NOVEMBER 14, 2007, THE DEALER HAD NOT INSPECTED THE TIRES. THE TOW TRUCK OPERATOR FELT THAT THE TIRE WAS DEFECTIVE. THERE IS A RECALL FOR THE TIRES: TREAD/BELT (NHTSA CAMPAIGN ID NUMBER 05T022000); HOWEVER, THE MANUFACTURER HAD NOT VERIFIED IF HIS TIRES WERE INCLUDED. THE FAILURE MILEAGE WAS 16,000 AND CURRENT MILEAGE WAS 25,000.

Nov 14, 2007

CONTINENTAL CONTITRAC TR LT275/70R18 TIRES BOUGHT 3 FORD F-350 BRAND NEW WITH THESE TIRES ON THEM AND WE HAD A BLOWOUT ON ONE TRUCK ON THE HIGHWAY AND YOU CAN SEE THE SIDEWALL IS BLISTERING ON THE OTHERS- 15 TIRES IN TOTAL. THERE IS A RECALL ON THESE TIRES IN CANADA BUT NOT IN THE US.*JB

Jan 20, 2007

DT*: THE CONTACT STATED WHILE TOWING A DOUBLE AXLE TRAILER AT 55 MPH ON NORMAL ROAD CONDITIONS ONE OF THE TRAILER'S TIRES EXPLODED. THE TIRE FAILURE WAS NOT APPARENT UNTIL THE CONTACT WAS ALERTED BY ANOTHER DRIVER. THE TRAILER DOUBLE AXLE PREVENTED THE CONTACT FROM LOOSING CONTROL OF THE VEHICLE. THERE IS NOT DOT# FOR THE MISSSION TIRES.

Jul 07, 2006

ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE

4 complaints

VEHICLE WOULD NOT START,A/C , PERFORMANCE, ENGINE LIGHT SLUGGISH TAKE OFF, PERFORMANCE, WHITE SMOKE AND EGR LEAKING DIESEL FUEL ON TOP OF MOTOR, THIS TRUCK HAS HAD TWO REBUILT ENGINES UPON THE FIRST 50,000MILES.ENGINE COVERED IN OIL, FUEL INJECTOR MAIN PROBLEM STARTED WITH OVERHEATING. *TR

Jan 10, 2012

TRUCK RUNS ROUGH, CHECK ENGINE LIGHT COME ON, FUEL SENSOR ERROR. THERE SEEMS TO BE QUITE A FEW SIMILAR COMPLAINTS. DEALERS STATED FUEL TANKS ARE CORRODING. WHY HAS THERE NOT BEEN A RECALL? THIS IS A MANUFACTURING PROBLEM. FORD SHOULD DEAL WITH IT OR MADE TO. *KB

Nov 28, 2011

MY TRUCK STARTING LOSING POWER LITTLE BY LITTLE OVER A SHORT PERIOD OF TIME. THE CHECK ENGINE LIGHT CAME ON & I TOOK IT TO THE FORD DEALERSHIP.THEY ADVISED ME THAT THE EGR SYSTEM WAS FAILING & THE COST IS $2500.00. THEY ALSO TOLD ME THAT FORD KNEW ABOUT THE PROBLEM & SHOULD HAVE RECALLED THIS PROBLEM..NOW I CAN'T DRIVE MY TRUCK WITHOUT WORRYING ABOUT ENGINE FAILURE (UNTIL IT'S FIXED)..INTERSTATE TRAVEL IS JUST ABOUT NON=EXISTENT FOR NOW..I WILL NOT LET MY WIFE DRIVE IT ANYMORE FOR NOW...THIS TRUCK ONLY HAS 75,000 MILES ON IT & FOR NOW IS NOT SAFE TO DRIVE ANYWHERE BUT SHORT DISTANCES... *TR

Oct 14, 2011

TRAILER BREAK CONTROLLER FAULTY, REPLACE EGR AND INJECTORS. 3/31/09~ REPLACE EGR COOLER, GASKET, FUEL FILTERS. 6/8/10~ ICP SENSOR & CONNECTOR FAULTY, CAC HOSE LEAKING, INJECTORS FAULTY, EGR VALVES CHANGED. 6/25/10~ 17 DAYS LATER BACK AGAIN IN SHOP FOR SAME ISSUE. TRUCK RUNS THEN WHEN YOU STOP THE TRUCK IN HOT WEATHER, IT WILL NOT RESTART FOR ABOUT 1 HOUR. TRUCK NEEDS TO COOL DOWN BEFORE RESTARTING. AND NO ONE CAN FIGURE OUT WHAT PROBLEM IS AND FIX IT CORRECTLY.

May 12, 2011

STEERING,SUSPENSION,WHEELS

3 complaints

DRIVING EAST ON INTERSTATE I10 EAST OF BENSON, AZ AT AROUND 75MPH, HIT A ROUGH PATCH OF ROAD AND THE VEHICLE WENT WILD, SHAKING, VIBRATING, LOSS OF CONTROL. I HIT THE BRAKES AND WENT ACROSS 3 LANES OF TRAFFIC INTO THE MEDIUM, WHERE I SKIDDED TO A STOP. I SEE FROM THE INTERNET THIS IS CALLED THE F350 DEATH WOBBLE! THE FORD F350 AND ALL RELATED VEHICLES NEED TO BE TAKEN OFF THE ROADS, THEY ARE A POTENTIAL DEATH TRAP. I COULD HAVE BEEN KILLED OR SERIOUSLY INJURED IN THIS ACCIDENT OR EVEN WORSE SOME INNOCENT FAMILY COULD HAVE BEEN KILLED IN A HEAD ON ACCIDENT! MY FORD F350 VEHICLE HAS AROUND 60,000 MILES, SUPERDUTY, 4X4. IT IS IN EXCELLENT CONDITION WITH A CAB OVER CAMPER.

Mar 26, 2021

DRIVING ON INTERSTATE AT APPROX 60 MPH, HIT PATCH IN ROAD, LOST CONTROL OF VEHICLE, DEATH WOBBLE, ALMOST CAUSED CRASH WITH 6 OTHER VEHICLES. WENT STRAIGHT TO DEALERSHIP TOLD IT WAS STEERING SHIMMY SHOCK FAILURE. ALIGNMENT. PAY FOR OUT OF POCKET, ALTHOUGH HAD SAME TRUCK IN SHOP FOR FRONT END REPAIRS IN JANUARY 2019.

Aug 05, 2019

WHILE TOWING MY LARGE CAMPER, ON THE FREEWAY, I HIT A BUMP. THE FRONT END OF THE TRUCK STARTED SHAKING VIOLENTLY. IT WAS ALL I COULD DO TO STOP THE TRUCK WITHOUT WRECKING. I HAD TO STOP IN THE TRAFFIC LANE. THIS WAS AN EXTREMELY DANGEROUS SITUATION. AFTER RESUMING TRAVEL, THE FRONT END WOULD SHIMMY AT ABOUT 45 MPH. I HAD TO DRIVE HOME AT 40 MPH...ROUGHLY ANOTHER 75 MILES. I THINK I HAVE SEEN AN ADVISORY LETTER FROM FORD, TO OWNERS, CONCERNING THIS. THERE ARE MANY, MANY INSTANCES OF THIS HAPPENING. ONE CAN FIND DOZENS OF EXAMPLES OF THIS HAPPENING IF ONE LOOKS ON LINE. NEITHER FORD NOR THE LOCAL FORD DEALER SEEMS TO BE AWARE OF THE PROBLEM. WE WERE TRAVELING AT ABOUT 60 MPH AT THE TIME OF THE INCIDENT.

May 24, 2017

SERVICE BRAKES

3 complaints

CORRUPTED V.I.N CALIBRATION IN PCM CAUSING A.B.S MODULE TO LOCK FRONT BRAKES AND NOT FULLY RELEASE. 2 FRONT ABS SENSORS READ 14% DIFFERENT SPEED FROM REAR CAUSING ABS TO SENSE AN ISSUE WHEN THERE IS NOT AN ACTUAL MECHANICAL ISSUE. WHEN A.B.S TRIES TO SLOW FRONT WHEELS IT DOES NOT FULLY RELEASE FRONT WHEELS CAUSING BRAKES TO OVERHEAT TO THE POINT OF CAUSING BRAKE FIRE. I HAVE WORKED WITH FORD DEALERSHIP TRYING TO RESOLVE THIS ISSUE BUT THEY CANNOT COME UP WITH A SOLUTION.

Nov 09, 2017

Fire: 1

TL* THE CONTACT OWNS A 2006 FORD F-350. WHILE DRIVING APPROXIMATELY 70 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND WITHOUT WARNING. THE CONTACT WAS ABLE TO AVOID A CRASH. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE REAR DRIVER AND PASSENGER SIDE BRAKE CALIPERS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT MENTIONED THAT THE REAR BRAKES WERE PREVIOUSLY REPLACED 10,000 MILES PRIOR TO THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 75,000. MA 10/22/2015 THE CONSUMER STATED HE EXPERIENCED COMPLETE BRAKE FAILURE ALONG WITH THE LOSS OF BRAKE FLUID. ALSO, THE BRAKES BECAME DISABLED ON THE TRAILER, THE CONSUMER WAS TOWING. UPDATED 12/09/15.*JB

Aug 18, 2015

THE VEHICLE SHOOK AT 65 MPH AND SHIMMIED WHEN THE BRAKES WERE APPLIED. WE FIRST HAD TIRE ROTATED AND BALANCED AND A FRONT END ALIGNMENT WITH THE REPLACEMENT OF RIGHT SIDE BALL JOINTS. IT DID NOT CORRECT THE PROBLEM. WHEN WE RETURNED THE VEHICLE TO THE DEALER FOR FURTHER REPAIR, THE DEALER TOOK US BACK TO LOOK AT THE REAR BRAKES. THE BACKING PLATES HAD FAILED DUE TO RUST AND THE PINS FOR THE PARKING BRAKE SHOES HAD PULLED THROUGH. THE DEALER REPLACED BOTH ROTORS, BOTH BRAKE SHOES, THE BACKING PLATES AND THE PADS FOR THE DISK BRAKES.

Apr 16, 2015

ELECTRICAL SYSTEM

3 complaints

TL* THE CONTACT OWNS A 2006 FORD F350. THE CONTACT STATED THAT THE BATTERIES IN THE VEHICLE KEEP GOING DEAD AND THE ALTERNATOR IS ALSO DEFECTIVE. THE DEALER CANNOT FIND THE FAILURE BUT THE OWNER THINKS THE FAILURE IS AN ELECTRICAL SHORT. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER HAD BEEN NOTIFIED BUT DID NOT OFFER ANY ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 100,000.

Sep 22, 2010

TL* THE CONTACT OWNS A 2006 FORD F-350 DIESEL SD. THE CONTACT STATED THAT THE BRAKES WOULD NOT OPERATE PROPERLY WHEN HAULING A FOREST RIVER CEDAR CREEK RV TRAILER. THE CONTACT STATED THAT THE DEALER COULD NOT REPAIR THE VEHICLE BUT A CERTIFIED MECHANIC WAS ABLE TO REPLACE THE PRODIGY. THE FAILURE WAS CORRECTED. THE FAILURE AND CURRENT MILEAGE WAS 44,504. THE CONSUMER PURCHASED THE VEHICLE WITH A FACTORY INSTALLED TOWING PACKAGE TO PULL HIS 5TH WHEEL TRAVEL TRAILER. THE CONSUMER THEN PURCHASED A NEW 5TH WHEEL TRAVEL TRAILER THAT WAS EQUIPPED WITH FACTORY INSTALLED BRAKE CONTROLLER FOR THE TRAILER. THE CONSUMER SOON DISCOVERED THAT THE TOWING PACKAGE FOR THE F-350 DID WORK WHEN APPLYING THE BRAKE WHEN TOWING THE TRAVEL TRAILER. THE CONSUMER STATED THE FACTORY INSTALLED BRAKE SYSTEM ONLY WORKED WHEN IT WAS APPLIED MANUALLY, WHEN TRYING TO AVOID AN ACCIDENT OR STOP SUDDENLY. UPDATED 06/22/11

Sep 20, 2010

TL* - THE CONTACT OWNS A 2006 FORD F350. THE VEHICLE CAUGHT ON FIRE. THE FRONT DRIVER'S SIDE HALF OF THE MOTOR WAS REPORTED TO BE THE CAUSE OF THE FIRE. THE FAILURE MILEAGE WAS 10,000. THE CONTACT HAS PICTURES. A FIRE REPORT WAS FILED. THERE WERE NO WARNING INDICATORS. THE VEHICLE WAS DESTROYED. A HOUSE AND TWO VEHICLES WERE ALSO DAMAGED. THERE WERE NO INJURIES.

Mar 19, 2007

Fire: 1

UNKNOWN OR OTHER

2 complaints

At highway speeds hitting a bump or small pothole the steering wheel vibrates to the point of almost losing control. If I didn't have two hands on the wheel I possibly could have lost control of my vehicle and crashed

Oct 05, 2021

I SLOWED TO LET A VEHICLE PASS ON A NARROW STREET. WHEN I PRESSED THE ACCELERATOR TO GET MY 2006 FORD F350 WITH THE 6.0L POWERSTROKE DIESEL ENGINE BACK UP TO 25 MILES PER HOUR, THE GAS PEDAL PULLED ITSELF TO THE FLOOR AT ABOUT 15 MILES PER HOUR AND WOULD NOT COME OFF THE FLOOR. I HAD TO STAND ON THE BRAKES AND PUT THE TRUCK IN NEUTRAL, THEN USE MY FOOT TO GET UNDER THE GAS PEDAL AND RETURN IT TO IT'S NORMAL OPERATING POSITION. AFTER, I DROVE TO MY MECHANIC AND HE SAID THE ELECTRICAL SENSOR IN THE GAS PEDAL WAS PROBABLY BAD AND THE ENTIRE ASSEMBLY NEEDED REPLACED. THIS INCIDENT ALMOST CAUSE ME TO REAR END A PERSON AT THE STOP SIGN IN FRONT OF ME AND PEDESTRIANS CROSSING THE ROAD IN THE CROSSWALK.

Nov 14, 2018

STEERING,SERVICE BRAKES, HYDRAULIC

2 complaints

TL*THE CONTACT OWNS A 2006 FORD F-350 HEAVY DUTY. THE CONTACT STATED THAT THERE WERE FOUR BOLTS ATTACHED TO THE ENGINE THAT CONTROLLED BRAKES AND STEERING. WHILE DRIVING AT APPROXIMATELY 5 MPH, HE ATTEMPTED TO BRAKE AND WAS UNABLE TO SLOW DOWN; HE WAS ALSO UNABLE TO STEER. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THE FOUR BOLTS BROKE AND CAUSED THE FAILURE. THE FOUR BOLTS WERE REPLACED AT THE DEALERSHIP. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE VIN WAS UNAVAILABLE. THE CURRENT MILEAGE WAS APPROXIMATELY 36,000. THE FAILURE MILEAGE WAS APPROXIMATELY 35,000.

Nov 16, 2010

TL*THE CONTACT OWNS A 2006 FORD F350. THE CONTACT STATED THAT THE BRAKES WILL LOCK AND CAUSE THE CALIPERS TO BURN. A SMALL FIRE OCCURRED DURING ONE OF THE FAILURES. THE BRAKES AND CALIPERS HAVE BEEN REPLACED FOUR TIMES, MOST RECENTLY ON APRIL 22, 2007. THE DEALER STATED THAT THE CAUSE OF THE FREQUENT FAILURES COULD BE DUE TO SEVERAL REASONS; HOWEVER, THEY WERE UNABLE TO DIAGNOSE THE EXACT CAUSE OF THE FAILURES. THE MANUFACTURER ASSISTED WITH THE FIRST FOUR FAILURES, BUT WOULD NOT ASSIST WITH THE CURRENT ONE. THE VEHICLE IS CURRENTLY AT THE DEALER BEING REPAIRED. THE CURRENT MILEAGE WAS 66,672 AND FAILURE MILEAGE WAS 800. UPDATED 10/14/08 *BF THE CONSUMER ALSO STATED HE HAS HAD A PROBLEM WITH THE STEERING WHEEL. UPDATED 10/16/08. *JB

Apr 23, 2008

Fire: 1

SUSPENSION,TIRES

2 complaints

1. TRAVELING AT 65 MPH HITTING A BUMP IN THE ROAD 2. FRONT AXLE BEGINS OSCILLATING WITH SUCH VIOLENCE THAT CONTROL OF THE TRUCK IS DIFFICULT UNTIL SLOWED DOWN, THE ENTIRE VEHICLE SHAKES TO THE POINT YOU FEEL IT WILL COME APART. I WAS TRAVELING ON A HIGHWAY WHEN I EXPERIENCED THIS. I NEARLY CAUSED AN ACCIDENT. I'M TERRIFIED WHEN THIS WILL HAPPEN ON A ICY ROAD. SOMEONE IS GOING TO GET KILLED. 3. NOTHING. APPARENTLY THERE IS NO FIX AS IT IS UNKNOWN. FORD IS AWARE OF THE PROBLEM BUT REFUSES TO BE HELD RESPONSIBLE. VEHICLE INFORMATION: ? 2006 ? FORD ? F350 ?? ENTIRE FRONT SUSPENSION COMPONENT ? VIN - [XXX] ? TIRES BFG ALL TERRAIN 325/65 R18. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Oct 28, 2010

I HAVE HAD TWO (2) F350 2006 SUPER DUTY FORD TRUCKS THAT THE WHEEL BEARINGS ARE COMPLETELY GONE AT 54,000 MILES AND AT 58,000 MILES. COSTING AT TOTAL OF $2,200.00. *TR

Feb 08, 2008

SUSPENSION,ENGINE

1 complaint

The contact owns a 2006 Ford F-350. The contact stated that while driving 35 MPH, the front of the vehicle started to wobble. While driving over a pothole, the vehicle wobbled violently. The contact was unable to control the vehicle while driving over 35 MPH. While driving at an undisclosed speed, the contact detected smoke coming from the vehicle. The engine warning light was illuminated. The contact called the local dealer, who informed him there were no recalls. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The approximate failure mileage was 99,856.

Dec 29, 2023

EQUIPMENT

1 complaint

While performing a lift of a 520-pound load in a boom position rated for 575 pounds, the crane abruptly failed due to a faulty weld and dropped the load approximately 18 inches, causing minor injuries to the crane operator. There was no sign of trouble before the failure. The failed weld was a circumferential weld between the support pillar and the bearing mount. This was concealed inside the base of the boom assembly and this part arrived already assembled. The skirt that extends from the boom assembly over the bearing mount caught on the pillar and stopped the boom from falling off the pillar entirely. The weld had a full bead but no penetration around most of its circumference. After painting this would have been hard to inspect visually even with the appropriate portion disassembled. Other reviews posted on Amazon.com, where the crane was purchased, show the same kind of deficient welding. The problem was reported to Amazon through a customer service representative and through their safety issue reporting system but they have made no acknowledgement of the issue and have not asked for more details. The broken component has since been repaired and returned to service but photographs of the failure are available.

Aug 18, 2023

Injuries: 1

SERVICE BRAKES, AIR,AIR BAGS

1 complaint

The contact owns a 2006 Ford F-350. The contact stated that while driving at approximately 35 MPH, the brake pedal was depressed, and the brake pedal remained on the floorboard. The vehicle crashed into another vehicle. The contact stated that the air bags failed to deploy. The vehicle was restarted but the failure persisted. A police report was filed. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the ABS needed to be replaced. The manufacturer was notified of the failure. The approximate failure mileage was 184,000.

May 26, 2023

Crash: 1

SUSPENSION,STEERING

1 complaint

Vehicle has experienced "death wobble," a common and well documented occurrence in Ford F250 and F350 model trucks. This has occurred on multiple occasions since 2006, and most recently on 4/26/2022. The incident occurred while traveling approximately 45 MPH, and hitting a small bump in the road. When the "death wobble" occurs, the vehicle shakes violently and is difficult to control. This creates a hazardous situation for the occupants of the vehicle and other vehicles/pedestrians in the vicinity of the vehicle. Prior and current attempts to contact Ford service departments, typically involves Ford stating there is not a recall and any repair outside of warranty are the responsibility of owner. The vehicle is available for inspection upon request. There is no warning prior to the "death wobble," and occurs when the vehicle is travelling at speed more than 45 MPH.

Apr 28, 2022

AIR BAGS,SEATS

1 complaint

TL* THE CONTACT OWNS A 2006 FORD F-350. WHILE DRIVING 35 MPH ON THE INTERSTATE, THE DRIVER LOST CONTROL DUE TO BLACK ICE. THE CONTACT DROVE INTO A DITCH. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS TOWED OUT OF THE DITCH. THE CONTACT STRUCK THE CENTER CONSOLE AND SUSTAINED A CONCUSSION, AND SEVERE PAIN TO THE HEAD, NECK, AND SHOULDERS. THE DRIVER SUSTAINED A CONCUSSION AND ANOTHER PASSENGER SUSTAINED UNDISCLOSED INJURIES. MEDICAL ATTENTION WAS REQUIRED. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT DESTROYED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER INFORMED THE CONTACT THAT THE VEHICLE'S SEAT WAS CONSIDERED A FIFTH SEAT FOR ANY INDIVIDUAL. THE FAILURE MILEAGE AND VIN WERE UNKNOWN.

Feb 06, 2017

Crash: 1

Injuries: 3

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

1 complaint

WHEN MERGING ON FREEWAY. TRUCK KEPT ACCELERATING AFTER LETTING OFF GAS PEDAL. SLAMMED ON BRAKES TO SLOW TRUCK. TRUCK KEPT GOING FASTER AND HAD NO CONTROL OF SPEED OR WAY TO STOP TRUCK. AFTER INCIDENT NOW TAC ODOMETER ON DASH NEEDLE WONT GO BACK TO ZERO AFTER YOU SHUT TRUCK OFF CRUISE CONTROL WAS OFF AND NO FLOOR MATS IN TRUCK.

Feb 09, 2016

STEERING,SUSPENSION,ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

FORD F-350 2006 COMPLAINT. WE HAVE EXPERIENCED VIOLENT SHAKING (SHIMMYING) WHEN THE TRUCK HITS A BUMP ON THE HIGHWAY AND AS A RESULT, EXTREME DIFFICULTY MAINTAINING THE VEHICLE ON THE ROAD. OUR FIRST EXPERIENCE WAS IN AUGUST 2015, ON THE INTERSTATE HIGHWAY WHILE TRAVELLING AT 75MP. WE HIT A BUMP AND THE TRUCK / STEERING WHEEL SHOOK VIOLENTLY FOR ABOUT 10 SECONDS CAUSING US TO SWERVE ACROSS LANES AND STRUGGLE TO KEEP THE TRUCK IN THE LANE AND OUT OF TRAFFIC'S WAY. WE HAVE SINCE EXPERIENCED THIS PROBLEM FOUR MORE TIMES HITTING BUMPY HIGHWAYS AT SPEEDS AS LOW AS 50MMP AND AS RECENT AS 2 WEEKS AGO. WE HAVE CHECKED IT OUT AND OUR MECHANIC ADVISED THAT HE COULD NOT FIND ANYTHING WRONG. IT HAS BEEN A GREAT CONCERN OF OURS AS IT PUTS OUR LIVES (AND THOSE ON THE ROAD WITH US) AT DANGER WHEN THIS ISSUE OCCURS. ADDITIONALLY, EVERY TIME THE VIOLENT SHAKING OCCURS, IT THROWS OFF THE ALIGNMENT AND BALANCING FOR THE TRUCK. WE HAVE JUST RECEIVED A LETTER FROM FORD ADVISING OF THIS PROBLEM AND I HAVE CALLED THE SERVICE CENTER FROM THE FORD DEALER WE BOUGHT THE VEHICLE FROM. FORD IS NOT ASSUMING RESPONSIBILITY FOR ANY DIAGNOSIS OR REPAIRS TO THESE DEFECTS AT THIS TIME. OUR TIRE PRESSURE IS IN KEEPING WITH FORD'S RECOMMENDATIONS AS THEY SUGGEST IN THEIR LETTER. FORD F-350 TRUCKS SHOULD NOT BE APPROVED FOR USE ON HIGHWAYS AS THIS DEFECT COULD RESULT IN FATAL ACCIDENTS IF THE SHAKING CANNOT BE CONTROLLED. ALSO, FORD SHOULD BE RESPONSIBLE FOR REPAIRING THE FAULTY TRUCKS.

Jan 18, 2016

ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM

1 complaint

TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THAT WHEN THE IGNITION WAS TURNED TO THE ON POSITION, THE ENGINE DID NOT START. AFTER SEVERAL ATTEMPTS, THE ENGINE STARTED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT TAKEN TO A DEALER OR DIAGNOSED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 170,000. UPDATED 08/02/16*LJ UPDATED 08/09/16.*JB

Nov 30, 2015

SUSPENSION,POWER TRAIN

1 complaint

TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE INDEPENDENTLY SWAYED SIDE TO SIDE WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, WHERE IT WAS DIAGNOSED THAT THE DRIVE SHAFT, CASE SHIFTER, TRANSMISSION, LIFT PUMP, TRANSFER CASE, LEFT CALIBER, FUEL LINE AND REAR SHAFT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 131,000. MA 08/13/15 UPDATED 09/01/2015*LJ UPDATED 10/14/2015*JS

Jun 24, 2015

ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

2006 FORD F-350 6.0 DIESEL CAB AND CHASIS -- EGR VALVE 1ST TIME FIXED BY FORD DEALER NO COST, EGR VALVE 2ND TIME FIXED AT COST, EGR VALVE 3RD TIME BY-PASSED, 16 FUEL INJECTORS REPLACED. DELAMINATING GAS TANK, OVER A DOZEN FUEL FILTERS AT $60,00 A POP, NEW FUEL PUMP, NEW GAS TANK, 8 MORE NEW FUEL INJECTORS. POSSIBLE TURBO ISSUES AND I MAY BE FORGETTING SOMETHING. *TR

Oct 21, 2014

FUEL SYSTEM, DIESEL,ENGINE

1 complaint

WHILE DRIVING ON HIGHWAY F-350 LOST POWER, SHUT OFF AND WOULD NOT RESTART. NUMEROUS PROBLEMS WITH FUEL/TURBO. REPLACE TURBO INJECTORS, EGR VALVE, FICM, FUEL INJECTOR, REGULATOR, AND HIGH PRESSURE OIL PUMP. *TR

Aug 20, 2013

VEHICLE SPEED CONTROL

1 complaint

TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, THE VEHICLE LOST ACCELERATION POWER AND STALLED. THE CONTACT STATED THAT SHE RESTARTED THE VEHICLE AND DROVE IT TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE TURBO CHARGER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

Jun 26, 2013

FUEL SYSTEM, DIESEL,FUEL/PROPULSION SYSTEM

1 complaint

FUEL TANK LINER IS DELAMINATING CAUSING FUEL SYSTEM TO CLOG UP AND TRUCK TO LOSE POWER. FORD REFUSES TO COVER THIS PROBLEM UNDER WARRANTY SAYING IT IS NOT THEIR FAULT. *TR

Nov 10, 2012

SERVICE BRAKES, HYDRAULIC

1 complaint

TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE FRONT PASSENGER WHEEL SEIZED. THE FAILURE OCCURRED BECAUSE THE CALIPER SEIZED. THE CONTACT ALSO STATED THAT THE WHEEL WAS EXTREMELY HOT AFTER THE FAILURE OCCURRED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CALIPER WAS REPAIRED. THE FAILURE HAD SINCE RECURRED ON AN INTERMITTENT BASIS. THE VEHICLE WAS EITHER TAKEN BACK TO THE DEALER FOR REPAIR OR THE CONTACT PERFORMED THE REPAIRS HIMSELF. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 7,000.

Apr 16, 2012

Fire: 1

STEERING,SUSPENSION,ENGINE AND ENGINE COOLING

1 complaint

THIS VEHICLE SINCE NEW HAS HAD NUMEROUS INCIDENTS WITH A SEVERE UNCONTROLLABLE SHIMMY IN FRONT END AND STEERING WHEEL.I HAVE HAD IT TO THE DEALER NUMEROUS TIMES AND THEY TELL ME THERE IS NOTHING WRONG WITH IT. FORD HAS SENT A FEW NOTIFICATIONS STATING THAT THEY ARE AWARE OF THE PROBLEM,BUT THAT IT IS JUST CAUSED FROM IMPROPER INFLATION.I HAVE SET THE TIRES TO MANUFACTURERS RECOMMENDED PSI WEEKLY,AND DOESN'T MAKE A BIT OF DIFFERENCE.FORD IS CLOSING THEIR EYES ON THIS ONE, AND IT IS GOING TO COST LIVES!!!.WHEN THIS OCCURS YOU HAVE ABSOLUTELY NO CONTROL OF THE VEHICLE.ANOTHER PROBLEM WITH THIS VEHICLE IS THE ENGINE IS JUNK. MY VEHICLE HAS 43000 MILES CURRENTLY,AND HAS HAD THE MOTOR TAKEN OUT OF IT TWICE ALREADY FOR REPAIRS!!!,AND HAS BEEN TO DEALER AT LEAST 6 OR 7 TIMES.I OWN A SMALL TREE CARE COMPANY AND REALLY CANT AFFORD A $45000 MISTAKE TO A MULTI BILLION DOLLAR COMPANY. *TR

Jan 09, 2012

ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE,POWER TRAIN

1 complaint

TL* THE CONTACT OWNS A 2006 FORD F-350. WHILE DRIVING APPROXIMATELY 50 MPH, THE CONTACT DROVE OVER AN UNEVEN ROAD SURFACE AND THE FRONT END OF THE VEHICLE BEGAN TO SHAKE VIGOROUSLY. THE VEHICLE WOULD ALSO SHAKE ABNORMALLY WHEN DECELERATING. THE CONTACT STATED THAT IN ADDITION, THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED, THE VEHICLE WOULD ERRATICALLY SHIFT, AND THE FUEL TANK WAS DELAMINATING. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS BUT THE TECHNICIANS WERE UNABLE TO DETERMINE THE CAUSE OF THE SHAKING. THE TECHNICIANS WERE ABLE TO DETERMINE THAT THE TRANSMISSION SHIFT SENSOR AND THE FUEL TANK WOULD HAVE TO BE REPLACED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TRANSMISSION WAS REBUILT. AND THE TRANSMISSION SHIFT SENSOR WAS REPLACED. THE FUEL TANK WAS NOT REPLACED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

Dec 13, 2011

SEATS

1 complaint

FRONT CENTER SEAT BACK HAS FAILED DUE TO CRACK IN PLASTIC BODY STRUCTURE. RESULTS IS THE BACK REST IS NOT SUPPORTING CENTER PASSENGER BACK PROPERLY. *TR

Aug 18, 2010

STEERING,ELECTRICAL SYSTEM

1 complaint

AT 200AM TODAY MY HORN ON MY 2006 F 350 STARTED BLOWING. BY THE TIME I REALIZED WHAT WAS GOING ON THE WIRES HAD STARTED TO SMOKE UNDER THE HOOD. I HAD TO DISCONNECT BOTH BATTERIES IN ORDER FOR THE HORN TO STOP. THIS IS THE FIRST TIME THIS IS HAS HAPPENED TO THIS TRUCK. NO OTHER PROBLEMS TO REPORT AT THIS TIME. I WILL BE HAVING IT TOWED TO A DEALER TODAY

Feb 25, 2010

STEERING,SERVICE BRAKES, HYDRAULIC,ELECTRICAL SYSTEM

1 complaint

THE FORD F-350 TRUCK I BOUGHT IS DEFECTIVE, AS EVIDENCED BY THE 7 POWER STEERING AND BRAKE REPAIRS REQUIRED IN THE PAST 3 YEARS, ALONG WITH THE ELECTRICAL SYSTEM AND RING AND PINION REPAIR. I HAVE CONTACTED FORD 24 TIMES, I HAVE FILED A COMPLAINT WITH THE MN BETTER BUSINESS BUREAU AND THE MN ATTORNEY GENERAL'S OFFICE. I BELIEVE THE TRUCK WAS MANUFACTURED IN A FAULTY MANNER, AND I AM AFRAID THE TRUCK MAY BE DANGEROUS TO DRIVE. I NEED YOUR HELP IN OBTAINING CREDIT TOWARDS A NEW TRUCK OR A NEW TRUCK DUE TO THE UNACCEPTABLE NUMBER AND TYPE OF REPAIRS REQUIRED. *TR

May 15, 2009

STEERING,ENGINE AND ENGINE COOLING,POWER TRAIN,EQUIPMENT

1 complaint

TL*THE CONTACT OWNS A 2006 FORD F-350. THE VEHICLE WOULD CRANK, BUT NOT START. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE OIL CONTROL MODULE DID NOT HAVE ENOUGH PRESSURE TO START THE MOTOR. THE DEALER REPLACED THE HEAD GASKET. THE RADIO VOLUME TURNED ALL THE WAY UP INTERMITTENTLY AND WAS REPLACED. WHILE DRIVING BETWEEN 5-10 MPH IN TOW HAUL MODE, THE TRANSMISSION WOULD NOT SWITCH GEARS WHEN MAKING A LEFT HAND TURN. THE DEALER UPDATED THE CODES FOR THE TRANSMISSION; HOWEVER, THE FAILURE CONTINUED. WHEN THE BRAKES WERE APPLIED, THERE WAS A LOSS OF STEERING. THE FAILURE MILEAGE WAS 12,000 AND CURRENT MILEAGE WAS 34,234.

Feb 14, 2008

2006 FORD F-350 Problems & Complaints

Complaints by Component

Frequently Asked Questions

How many problems does the 2006 FORD F-350 have?

What are the most common problems with 2006 FORD F-350?

Where does this 2006 FORD F-350 problem data come from?

Other Years - FORD F-350

Other FORD Models

Similar Brands