2008 FORD F-350 Problems & Complaints
Real owner complaints and problems reported to the National Highway Traffic Safety Administration (NHTSA). View common issues by component.
231
Complaints Reported
Complaints by Component
STEERING
38 complaints
Steering went out , wouldn’t return to center
Feb 13, 2023
Power steering pump replaced with new unit. Major steering issues. Will not turn at some points. Almost caused 3 accidents on 10/22/2021. Have had front end and power steering pump replaced.
Oct 23, 2021
Death wobble and learned about class action after I had front end repaired with complete overhaul ball joints etc in January 2018 ($2100 plus dollars) by my mechanic. May 16, 2021 experienced 3 incidents of death wobble in Oklahoma City enroute toTulsa, Oklahoma. See my mechanic on June 1, 2021.
May 30, 2021
ON INTERSTATE PASSING IN LEFT LANE HIT A ROUGH PATCH TRUCKS STARTS SHAKING SO BAD I THOUGHT IT WAS GOING TO FLIP. COULD NOT GET TO SHOULDER SO HAD TO GO IN THE MEDIAM IT WAS NOT A FLAT SPOT IT WAS A HILL SO I WENT STRAIGHT AND NOT AT AN ANGLE IF I HAD I WOULD OF FLIPPED. THIS IS NOT THE FIRST TIME. IFRIST TIME I HAD APPROX $3000.00 OF FRONT IN WORK DONE TRYING TO FIX THE PROBLEM, BUT IT DID NOT.
May 13, 2021
TL* THE CONTACT OWNS A 2008 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE POWER STEERING AND BRAKING SYSTEM WOULD SUDDENLY MALFUNCTION CAUSING THE DRIVER TO NEARLY LOOSE CONTROL OF THE VEHICLE. DURING THE FAILURES, THE STEERING WHEEL WOULD NOT TURN IN EITHER DIRECTION AND THE BRAKE PEDAL WAS DIFFICULT TO DEPRESS. THE CAUSE OF THE FAILURES WERE NOT DETERMINED. THE LOCAL DEALER TAYLOR MOTOR COMPANY LOCATED AT 524 RUSS AVE, WAYNESVILLE, NC 28786 WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 211,000.
Feb 11, 2021
+ 33 more complaints for this component
ENGINE AND ENGINE COOLING
38 complaints
TL* THE CONTACT OWNS A 2008 FORD F-350. THE CONTACT STATED THAT THE EXHAUST MANIFOLD DETACHED FROM THE HEAD OF THE ENGINE AND CAUSED EXHAUST FUMES TO ENTER THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO CONFIRMED THE FAILURE. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS CONTACTED AND ADVISED THE CONTACT TO TAKE THE VEHICLE TO A FORD DEALER. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS APPROXIMATELY 53,000. ...UPDATED 10/19/17 *BF CONSUMER STATED MY INDEPENDENT MECHANIC CONFIRMED THE DRIVERS SINE EXHAUST MANIFORD HAD SEPARATED FROM THE HEAD BECAUSE ALL OF THE STUDS & KNOTS WERE RUSTED OFF. UPDATED 10/3/18*JB
Aug 10, 2017
ON SEPTEMBER 30, 2014, MY WIFE WAS ON HER WAY TO COLUMBUS, OHIO IN HER 2008 FORD F350 SUPER DUTY TURBO DIESEL TRUCK WITH 44,000 MILES. SHE'S PULLING HER 2014 26 LAKOTA TWO HORSE TRAILER WITH LIVING QUARTERS WITH HER SHOW HORSE ($30,000) IN THE BACK. THE UNEXPECTED HAPPEN WHILE SHE WAS ON MD-51N NEAR CUMBERLAND, MARYLAND HEADING ACROSS A BRIDGE WITH HEAVY TRAFFIC AT 1230PM. THE CHECK ENGINE LIGHT CAME ON FOLLOWED BY A PULL OVER SAFELY' MESSAGE. TWENTY SECONDS (20 SECONDS) LATER, THE TRUCK COMPLETELY SHUT DOWN. WIFE WAS TRAVELING AT 70 MILES AN HOUR WHEN THE TRUCK SHUT DOWN, WHICH TURNED THE POWER STEERING OFF. THIS IS WHAT I CALL UNSAFE FOR ANYONE, ESPECIALLY WHEN PULLING A 26 HORSE TRAILER WITH AN EXTRA 1000LBS IN THE BACK WITH A HORSE. SHE WAS NOT ABLE TO GET COMPLETELY OFF THE ROAD BECAUSE IS SHUTDOWN ON THE BRIDGE BLOCKING THE RIGHT LANE WHICH ALMOST CAUSED A MAJOR ACCIDENT DUE TO THE VEHICLE SHUTTING DOWN ON HER. WHILE WAITING ON THE BRIDGE, HER TRAINER HAD TO TURN AROUND HIS EIGHTEEN WHEELER SO MY WIFE COULD UNLOAD HER HORSE AND LOAD IT IN HIS TRAILER. THIS COMPLETELY SHUTDOWN THE TRAFFIC ON MD-51N WHICH IS NOT SAFE UNLOADING AND LOADING A HORSE.AFTER SITTING ON THE SIDE OF THE ROAD WAITING FOR AAA TO COME TOW THE VEHICLE FOR OVER 1 HOURS, THE VEHICLE STARTED BACK UP AND SHE DROVE IT TO FORD CUMBERLAND, 10335 MT SAVAGE ROAD NW, CUMBERLAND, MD WITH THE CHECK ENGINE LIGHT STILL ON WITH A POLICE ESCORT SINCE THE SHERIFF OF CUMBERLAND SAT WITH MY WIFE ON MD-51N WAITING ON AAA. THIS IS AFTER SHE WAS ALMOST HIT BY A FEDEX EIGHTEEN WHEELER DUE TO NOT BEING ABLE TO GET TO A SAFE LOCATION FOR A TRUCK AND HORSE TRAILER DUE TO THE VEHICLE SHUTTING DOWN ON HER. THE DEALERSHIP FOUND THE PROBLEM: EXHAUST SENSOR. THEY WERE ABLE TO REPAIR IT AND SHE WAS ABLE TO CONTINUE ON WITH HER TRIP. HOW CAN THIS SENSOR GO OUT ON A TRUCK WITH ONLY 44,000 MILES ON IT? *TR
Oct 02, 2014
TWO 2008 FORD F-350. CONSUMER WRITES IN REGARDS TO A DESIGN FLAW IN BOTH VEHICLES CURRENT RADIATORS. *SMD FORD'S RECOMMENDATION WAS TO REPEATEDLY REPLACE THE PART AT A COST OF $ 1300. *JB
Apr 09, 2014
TL* THE CONTACT OWNS A 2008 FORD F-350. THE CONTACT WAS DRIVING 30 MPH WHEN WHITE SMOKE EMITTED FROM THE EXHAUST. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER ADVISED THE CONTACT THAT THE VEHICLE ENTERED INTO AN ABNORMAL SAFE MODE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 4,000 AND THE CURRENT MILEAGE WAS 27,000.
May 09, 2012
VEHICLE WAS SITTING AT IDLE WHEN BLEW UPPER RADIATOR HOSE. I REPLACED HOSE DUE TO FORDS EXCESSIVE CHARGE TO REPLACE ONE HOSE,WAS NOT NOTIFIED THAT DUE TO THE LOSS OF FLUID. RADIATORS HOT COLD CYCLES WERE EFFECTED, SO RADIATOR WAS EFFECTED AND CREATED A CRACK IN RADIATOR DUE TO CONSTANTLY CYCLING DUE TO THE LOSS OF FLUID CREATED FROM DEFECTIVE HOSE. NOW FORD WILL NOT COVER THE RADIATOR DUE TO SERVICE MANAGERS LACK OF INFORMING CLIENT TO KEEP HOSE FOR FORD CORPORATE TO REVIEW. OTHER PROBLEMS THAT AROSE BLOWN MOTOR. *TR
Apr 22, 2012
+ 33 more complaints for this component
STEERING,SUSPENSION
16 complaints
Death wobble. First experience was September 2019
Jul 20, 2023
DEATH WOBBLE OCCURS AT HIGHWAY SPEEDS IF BUMPS OCCUR CONSECUTIVELY CLOSE TOGETHER,THE ONLY WAY TO STOP WOBBLE IF YOU ABRUPTLY STOP,IT'S WORSE IF YOUR ON A TRANSITION RAMP TO ON COMING TRAFFIC.
Nov 22, 2020
I HAVE A 2008 FORD F-350 THAT I EXPERIENCED A VIOLENT, SHUDDERING, VIBRATION AT APPROXIMATELY 75 M.P.H. ON INTERSTATE-75 YESTERDAY, 09/19/2020, THAT ALMOST CAUSED ME TO CRASH. I LOOKED ONLINE AND THERE ARE MANY, MANY PEOPLE WHO HAVE AND ARE EXPERIENCING THE SAME, DANGEROUS PROBLEM. I FIRMLY BELIEVE THAT THERE SHOULD BE A RECALL OF THE AFFECTED F-250 AND F-350 VEHICLES AND FORD SHOULD REPAIRS THESE VEHICLES BEFORE ANYONE IS INJURED OR KILLED, IF THERE HASN'T BEEN SUCH A TRAJEDY OR TRAGEDIES ALREADY.
Sep 21, 2020
THE 2008, AS WELL AS OTHER YEARS OF THE FORD F-350 ARE KNOWN TO HAVE A PROBLEM WITH A FRONT-END SHIMMY OR "DEATH WOBBLE". I HAVE HAD SEVERAL THOUSAND DOLLARS OF WORK DONE TO MY F-350 IN ORDER TO RESOLVE THE DEATH WOBBLE PROBLEM. THE REPAIRS WORK FOR A TIME AND THEN, WITHOUT WARNING, THE DEATH WOBBLE RETURNS. THE FACT THAT THIS CAN OCCUR WITHOUT WARNING, AT HIGH SPEEDS, BY DRIVING OVER A VERY SMALL BUMP IN THE ROAD, MAKES THIS AN EXTRAORDINARILY DANGEROUS PROBLEM. I DON'T THINK I CAN ADEQUATELY DESCRIBE THE EXTREME NATURE OF THE DEATH WOBBLE. THE FRONT-END OF THE TRUCK IS BOUNCING LEFT AND RIGHT, THE ENTIRE VEHICLE IS TWISTING AND ROLLING, THE STEERING WHEEL IS BARELY CONTROLLABLE, ANYTHING LOOSE IN THE PASSENGER COMPARTMENT GOES FLYING AND KEEPING THE VEHICLE IN ITS LANE IS NOT ALWAYS POSSIBLE. REDUCING SPEED AS QUICKLY AS POSSIBLE IS THE ONLY RECOURSE AND THIS POSES A DANGER PARTICULARLY WHEN ON A HEAVILY TRAFFICKED HIGHWAY. THIS PROBLEM HAS BEEN KNOWN ABOUT FOR A LONG TIME AND FORD WILL NOT TAKE ANY RESPONSIBILITY. EVEN AFTER SPENDING THOUSANDS OF DOLLARS ON COMPLETE FRONT-END REBUILDS, AND IMPECCABLE MAINTENANCE, THE PROBLEM WILL SUDDENLY REOCCUR. THE DESIGN OF THIS FRONT-END IS FAULTY AND VEHICLE OWNERS SHOULD NOT CONTINUE TO BE RESPONSIBLE FOR THE COSTS OF MAINTAINING THIS FAULTY DESIGN AND BEING EXPOSED TO GREAT RISK.
Jul 25, 2018
AFTER HITTING A BUMP IN THE ROAD, THE TRUCK WILL SHAKE VIOLENTLY AND ATTEMPT TO GET OUT OF CONTROL. THE ONLY WAY TO CORRECT THIS IS BRING THE VEHICLE SPEED DOWN TO UNDER 20 MPH. THIS PROBLEM BEGAN OCCURRING SPORADICALLY ABOUT ONE YEAR AGO AND HAS GOTTEN CONSISTENTLY WORSE. IT IS SO SEVER THAT I HAVE DECIDED TO PARK THE VEHICLE OUT OF A CONCERN FOR SAFETY. I HAD THE VEHICLE INSPECTED AT THE LOCAL FORD DEALERSHIP APPROXIMATELY 3-4 MONTHS AGO AND THEY SAID EVERYTHING WAS FINE. TODAY, I RECEIVED IN THE MAIL A NOTICE MARKED "SPECIAL FIELD ACTION 09L02" THAT SAYS THE PROBLEM IS DUE TO TIRE INFLATION. I HAVE THE PROPER SIZE TIRES AND I KEEP THEM PROPERLY INFLATED. AFTER RESEARCHING THIS, I HAVE NOTICED THAT THIS PROBLEM DATES BACK TO 2005 AND FORD HAS SENT THIS SAME NOTICE OUT MANY TIMES. IT IS NOT A TIRE PROBLEM. I BELIEVE IT IS A KNOWN SUSPENSION PROBLEM AND IT IS DANGEROUS. THIS NEEDS TO BE A MANDATORY RECALL AND IT NEEDS TO BE PAID FOR BY FORD. I CALLED THEIR SERVICE LINE TODAY AND WAS TOLD MY VEHICLE WASN'T PART OF ANY NOTICE OR RECALL. THE PAPER I GOT TODAY SAYS "THIS NOTICE APPLIES TO YOUR VEHICLE" AND GOES ON TO GIVE MY VIN #. IT IS A BIG PROBLEM AND NOW IT HAS A BIG COVER-UP TO GO WITH IT.
Feb 05, 2018
+ 11 more complaints for this component
TIRES
14 complaints
TL* THE CONTACT OWNS A 2019 FORD F-350 SD, EQUIPPED WITH MICHELIN TIRES, TIRE LINE: LTX MS/2, TIRE SIZE: 245/75/R17, DOT NUMBER: B74345 (PARTIAL). THE CONTACT STATED WHILE DRIVING 75 MPH, THE FRONT DRIVER'S SIDE TIRE WENT FLAT AND THE STEERING CEASED. THE CONTACT DEPRESSED THE BRAKE PEDAL AND PULLED OVER TO THE SIDE OF THE ROADWAY. THE TIRE WAS REPLACED WITH THE SPARE TIRE. THE CONTACT STATED THAT IT WAS THE SECOND TIME THE FAILURE OCCURRED. THE FIRST TIME, THE FRONT PASSENGER SIDE TIRE WENT FLAT WHILE THE CONTACT WAS DRIVING AT AN UNDISCLOSED SPEED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THAT THERE WAS NO RECALL AND THAT THE TIRE WAS OVER THE WARRANTY COVERAGE PERIOD. THE FAILURE MILEAGE WAS 54,000. THE VIN WAS UNAVAILABLE.
Apr 05, 2021
TL* THE CONTACT OWNS A 2008 FORD F-350 SD EQUIPPED WITH BF GOODRICH RUGGED TERRAIN T/A TIRES, SIZE: 275/70R18. WHILE DRIVING APPROXIMATELY 50 MPH, THE TIRE TREAD DETACHED FROM THE FRONT DRIVER SIDE TIRE. VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS CONFIRMED THAT THE TREAD SEPARATED FROM THE TIRE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE FAILURE MILEAGE WAS 91,335 AND THE TIRE FAILURE MILEAGE WAS APPROXIMATELY 3,000.
Sep 12, 2016
I PURCHASED A 2008 FORD F-350 P/U TRUCK WITH THE ORIGINAL CONTINENTAL/CONTITRAC TIRES (LT275/70R18 125/122S). THEY ONLY HAVE APPROX. 31K MILES ON THEM AND THE TREAD SHOWING SIGNS OF SEPARATION AS OUTLINED IN A RECALL DATED MARCH 11, 2011. THERE HAVE BEEN NO ACCIDENTS, AND THAT IS WHAT I AM TRYING TO AVOID. I HAVE CONTACTED THE MANUFACTURER AND IT DOES NOT APPEAR THAT THEY WILL BE HELPFUL IN RESOLVING THIS MATTER. PLEASE HELP! *TR
Feb 02, 2015
DURING ROUTINE SERVICE I NOTICED THAT ALL FOUR OF MY MICHELIN LTX AT2 LT275-70R18 TIRES ARE CRACKING BETWEEN THE TREAD AND THE CENTER OF THE SIDE WALL, TIRES HAVE LESS THAN 20,000 MILES ON THEM AND THEY ARE LESS THAN THREE YEARS OLD. CONTACTED MICHELIN DIRECT, AND THEY ADVISED THERE WAS NOTHING THEY COULD DO FOR ME. THERE WEB SITE STATES THE TIRES HAVE A 6 YEAR WARRANTY AND A TREAD WARRANTY UP TO 2/32. TIRES HAVE 7/32 OF TREAD LEFT. I HAVE SEEN SEVERAL OTHER COMPLAINTS ABOUT CRACKING SIDE WALLS ON THE SAME MICHELIN TIRE IN DIFFERENT SIZES. MICHELIN HAS A PROBLEM, THEY ARE JUST LOOKING THE OTHER WAY. *TR
Jan 31, 2015
SECOND FAILURE OF CONTINENTAL TRUCK TIRES. *TR
Nov 18, 2013
+ 9 more complaints for this component
ENGINE
13 complaints
WE WERE HAULING A LOAD OF LOGS ABOUT AN HOUR AWAY EVERYTHING WAS FINE WHEN ALL OF THE SUDDEN THE TRUCK DOWN SHIFTED AND WHITE SMOKE STARTED POURING OUT FROM UNDER THE PASSENGER SIDE OF THE HOOD FOLLOWED BY FLAMES. WE HAD TO TRY TO GET OFF THE ROAD WHERE WE WERE THERE WAS NO WHERE TO PULL OFF AND FINALLY COULD SWING INTO A STATE GAMESLAND AND SOMEONE CALLED THE FIRE DEPT. I AM NOW OUT OF A TRUCK I JUST PURCHASED 2 MONTHS AGO AND MY VIN NUMBER ISN'T EVEN SHOWING UP
Apr 06, 2021
HAD THE TRUCK OVER HEAT MULTIPLE TIMES. HAD TO CHANGE THE COOLANT AND ALSO THE RADIATOR ON LONG WITH THE OIL COOLANT CONTAINER. HAS A TICKING SOUND AND HAS NOT YET GONE AWAY. HAVE TAKEN IT TO FORD DEALER AND THEY CAN'T FIGURE IT OUT. WOULD LIKE TO KNOW WHAT TO DO SINCE I HAVE SPENT A LOT OF MONEY AND THE PROBLEM HASN'T BEEN FIXED AND THE ONLY THING THE FORD DEALER TELLS ME IS TO TRADE IT IN FOR A NEW ONE. HELP1
Oct 22, 2019
FORD SHOULD BE HELD ACCOUNTABLE FOR THE 6.4 DIESEL AS MUCH AS THESE TRUCKS COST HARD WORKING AMERICANS, PAY CLOSE TO 30 THOUSAND DOLLARS FOR A PICKUP TRUCK THEN HAVE TO PAY ANOTHER 15 THOUSAND TO FIX THE MOTOR DUE TO IT NOT BEING BUILT CORRECTLY, JUNK RODS, HEAD BOLTS, HEADS, TURBOS, OIL LEVEL BEING RAISED BY 2 TO 3 GALLONS PER OIL CHANGE, DUE TO FUEL BEING PUMPED BACK INTO THE ENGINE, CAUSING SEVERE INTERNAL ENGINE PROBLEMS, IT'S NOT IF IT WILL BLOW BUT WHEN IT WILL, AS PER FORD MASTER MECHANIC. THIS IS A DANGEROUS SITUATION, TO KNOW AT ANY GIVING MINUTE WHILE DRIVING YOU'RE MOTOR COULD BLOW CAUSING LOSS OF CONTROL OF THE VEHICLE.
Jan 07, 2019
ENGINE DID NOT KICK OUT OF REGIN CAUSEING OVER HEAT
Nov 30, 2017
UPON RETURNING FROM A SHORT DRIVE I NOTICED OIL ON THE GROUND...HAD TRUCK TOWED TO LOCAL FORD DEALER ...WHEN INSPECTED I WAS INFORMED THE SELF CLEANING EXHAUST SYSTEM CAUSED THE RINGS TO WEAR PREMATURELY AND BUILD PRESSURE IN THE CRANKCASE CAUSING OIL TO SPEW OUT ANY OPENING IE THE DIPSTICK TUBE. A DIESEL ENGINE SHOULD HAVE BEEN EXPECTED TO LAST 2-3 TIMES THE 165,000 MILES ON THE TRUCK.
Apr 26, 2017
+ 8 more complaints for this component
SERVICE BRAKES, HYDRAULIC
10 complaints
The contact owns a 2008 Ford F-350. The contact stated that on several occasions while the accelerator pedal was depressed, the contact noticed a burning odor throughout the vehicle. The contact stated that the rear driver’s and passenger’s side wheels inadvertently locked without warning then released. No warning lights were illuminated. The vehicle was taken to the dealer where the brake pedal and plunger rod was replaced with a longer plunger rod; however, the failure recurred. The contact stated that while driving at an undisclosed speed, he depressed the brake pedal however, the vehicle failed to stop. The contact stated that he had to applied pressure to the brake pedal that was depressed down to the floorboard. As a result, the vehicle glided to a stop. No warning lights were illuminated. The vehicle was taken back to the dealer where it was diagnosed that brake pedal and the brake master cylinder needed to be replaced. The vehicle was repaired; however, the failure recurred after the vehicle was retrieved from the dealer. The contact stated that while the accelerator pedal was depressed, the front driver’s side wheel locked without warning and then released. The contact stated that he steered the vehicle off the roadway and was informed by another motorist that there was smoke underneath the vehicle. The contact stated that he was assist by Law Enforcement and advised to call the NHTSA Hotline. The vehicle was then taken back to the dealer where it was diagnosed that the brake caliper, front brake lock, brake pads, master cylinder and other undisclosed brake parts needed to be replaced. The vehicle was repaired; however, the failure recurred. The contact was advised by the technician to take the vehicle to Bob’s 151 transmission Center where it was diagnosed that the ABS had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the vehicle was too old, and no further assistance was provided. The contact stated that the call was disconnected. The failure mileage was approximately 70,000
May 24, 2023
MONDAY, JANUARY 3, 2011, WE WERE DRIVING ON A RURAL ROAD IN ROUTE TO SHARPS CHAPEL, TENNESSEE WHEN THE RIGHT SIDE FRONT PASSENGER CALIPER/ROTOR ASSEMBLY FAILED CAUSING SMOKING AND BURNING SMELL OF THE BRAKE SHOES FORCING ME TO PULL TO THE SIDE OF THE ROAD. AFTER ALLOWING THE BRAKES TO COOL, I CONTACTED AND DROVE TO MORRISTOWN FORD IN TENNESSEE AND THEY TO ATTEMPTED TO REPAIR THE BRAKES BY DISASSEMBLING AND CLEANING THE CALIPER/ROTOR SINCE THEY DID NOT HAVE THE PARTS AVAILABLE TO APPROPRIATELY RECTIFY THE SITUATION. THIS REPAIR WAS NOT EFFECTIVE AND THE PROBLEM HAS REPEATED ITSELF FOUR TIMES SINCE THEN, MOST RECENTLY ON OCTOBER 5, 2012. THIS APPEARS TO BE A VERY DANGEROUS VEHICLE DESIGN AND/OR PART FAILURE!! FORD NEEDS TO RECTIFY THIS PROBLEM!! *TR
Dec 26, 2012
PUSHED PARKING BRAKE WENT TO FLOOR , R&I REAR PARKING BRAKE BACKING PLATE RUSTED OUT ON BOTH SIDES OF TRUCK 2008 F350 4X4 LARIAT. *TR
Jan 12, 2012
DRIVER, ATTEMPTING TO STOP FOR A LIGHT RAIL CROSSING, DEPRESSED BRAKE AND ACCELERATOR SIMULTANEOUSLY, MOVING FORWARD INTO THE PATH OF ONCOMING TROLLEY. VEHICLE A TOTAL LOSS. DRIVER BELIEVES BRAKE AND ACCELERATOR PEDALS ARE TOO CLOSE TOGETHER AND ALIGNED WHEN DEPRESSED.
Jun 24, 2011
TL* THE CONTACT OWNS A 2008 FORD F-350 HD. THE CONTACT STATED THAT WHILE HAVING AN OIL CHANGE THE MECHANIC NOTICED THE REAR BRAKES ON THE PASSENGER SIDE WERE METAL ON METAL. THE DEALER STATED THAT THERE HAVE BEEN PROBLEMS WITH THE CALIBERS GOING BAD AND CAUSING THE BRAKE PADS AND ROUTERS TO FAIL AS WELL. THE DEALER REPLACED THE CALIBERS UNDER WARRANTY, BUT WOULD NOT REPLACE OTHER PARTS OF THE BRAKE SYSTEM. THE CONTACT FEELS THERE IS A DEFECT WITH THE CALIBERS USED ON THE VEHICLE. THE VIN WAS NOT ACCEPTED AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE AND CURRENT MILEAGES WAS 37000.
Sep 09, 2010
+ 5 more complaints for this component
SUSPENSION
7 complaints
TL* THE CONTACT OWNS A 2008 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE EXPERIENCED THE DEATH WOBBLE. THE CONTACT STATED THAT THE STEERING WHEEL SHOOK VIOLENTLY TO THE LEFT AND TO THE RIGHT. THE CONTACT SLOWED DOWN TO REGAIN CONTROL OF THE VEHICLE. THE CONTACT STATED THAT THE FAILURE RECURRED WHILE DRIVING OVER A BUMPY ROAD SURFACE. BEACH FORD (2717 VIRGINIA BEACH BLVD, VIRGINIA BEACH, VA 23452; 757-486-2717) WAS CONTACTED AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT SUBJECTED TO A RECALL. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 207,000.
Jun 24, 2020
WHILE DRIVING OVER 40 MPH IF A BUMP OR POTHOLE IS HIT THE TRUCK BOUNCES OR SHAKES VIOLENTLY AT THE FRONT. THE TRUCK HAD PREVIOUSLY DONE IT ONE OTHER TIME. THIS TIME THE TRUCK WAS TRAVEING ABOUT 55 MPH ON A 2 LANE HIGHWAY WHEN I HIT A DIP IN THE ROAD AND THE TRUCK STARTED VIOLENTLY BOUNCING AND WENT ACROSS THE OPPOSITE DIRECTION SIDE OF THE HIGHWAY. LUCKILY NO OTHER CAR WAS COMING BUT DAMAGE WAS DONE TO THE FRONT OF THE TRUCK WHEN IT WENT TO THE OPPOSITE SIDE OF THE ROADWAY. I HAVE SINCE PARKED THE VEHICLE UNTIL IT CAN BE FOUND WHAT CAUSED THE PROBLEM. I WILL HAVE TO CONTACT THE INSURANCE CO ABOUT THE FRONT END REPAIR BUT NOT UNTIL IT IS SAFE TO DRIVE.
Feb 11, 2018
TL* THE CONTACT OWNS A 2008 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING OVER 40 MPH, THE VEHICLE WOBBLED AND VIOLENTLY VIBRATED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER ON MULTIPLE OCCASIONS; HOWEVER, THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000.
Aug 09, 2016
TL* THE CONTACT OWNS A 2008 FORD F-350. WHILE DRIVING 65 MPH OVER A POTHOLE, THE VEHICLE BEGAN TO VIBRATE VIOLENTLY. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER, WHERE THE TRACK BAR BALL JOINT WAS REPLACED. THE FAILURE PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 22,000. UPDATED 03/24/15*LJ UPDATED 9/20/2017*CN
Feb 02, 2015
TL* THE CONTACT OWNS A 2008 FORD F-350 SUPER DUTY. THE CONTACT STATED THAT WHEN DRIVING 55-70 MPH OVER A ROAD BUMP, THE VEHICLE WOULD SHAKE UNCONTROLLABLY. THE CONTACT HAD TO APPLY PRESSURE TO THE BRAKE PEDAL IN ORDER TO CONTROL THE VEHICLE. THE FAILURE WAS EXPERIENCED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHO TEST DROVE THE VEHICLE, BUT WAS UNABLE TO DUPLICATE THE FAILURE. THE CONTACT TOOK THE VEHICLE TO A TIRE SPECIALIST WHO PERFORMED AN ALIGNMENT AND REPLACED THE TIRES AND SHOCKS HOWEVER, THE FAILURE WAS NOT CORRECTED. THE VEHICLE CONTINUED TO SHAKE UNCONTROLLABLY WHEN DRIVING OVER A ROAD BUMP. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 29,800 AND THE CURRENT MILEAGE WAS 30,000.
Nov 29, 2012
+ 2 more complaints for this component
WHEELS
7 complaints
NITTO DURA GRAPPLER 245/75R/17 FRONT LEFT TIRE BLEW CAUSING VEHICLE TO CRASH INTO GUARD RAILING ON INTERSTATE. THE VEHICLE WAS DRIVING ON I-75 SB NEAR MM 181 APPROXIMATELY 72 MPH. I WAS NOT MADE AWARE OF THE RECALL. ON MARCH 6,2015 I HAD ANOTHER TIRE BLOW AND I FILED A NITTO CLAIM NUMBER 804190 (THROUGH THE TIRE DEALERSHIP). I RECEIVED FROM NITTO THE SAME TIRE IN EXCHANGE. EVEN THOUGHT THIS TYPE OF TIRE WAS RECALLED ON SAFERCAR.GOV ON NOVEMBER 4, 2015. WHY WAS IT REPLACED BY NITTO WITH ANOTHER DEFECTIVE TIRE??? NOW MY VEHICLE IS TOTALED!
Mar 29, 2017
TL* THE CONTACT OWNS A 2008 FORD F-350. THE CONTACT STATED THAT THE RIMS ON THE VEHICLE WERE CRACKING. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000. ..UPDATED 12/11/14 *BF UPDATED 06/2/2015 *JS
Oct 16, 2014
TL* THE CONTACT OWNS A 2008 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE REAR PASSENGER SIDE TIRE BLEW OUT. THE CONTACT WAS INFORMED BY THE ROAD SIDE ASSISTANCE PERSONNEL THAT THE RIM WAS FRACTURED AND HAD CAUSED THE BLOW OUT. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC FOR THE REPLACEMENT OF THE RIM. AFTER THE REPAIR, THE CONTACT NOTICED THE FRONT PASSENGER SIDE RIM WAS FRACTURED AS WELL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. *TR
Apr 15, 2013
TL* THE CONTACT OWNS A 2008 FORD F-350 DIESEL. WHILE TRAVELING 70 MPH, THE CONTACT NOTICED THAT THE VEHICLE HAD BEGAN TO SLIGHTLY VIBRATE. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT ON THE FRONT DRIVER SIDE TIRE RIM, THERE WAS SIX INCHES OF THE TIRE RIM BEAD THAT WAS FRACTURED FROM THE RIM OF THE TIRE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE WHEEL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 44,000. ..UPDATED 04/26/12 *BF
Apr 16, 2012
TL* THE CONTACT OWNS A 2008 FORD F-350. THE VEHICLE WAS TAKEN TO THE DEALER TO HAVE TIRES REPLACED WHEN THE TECHNICIAN ADVISED THE CONTACT THAT THE FRONT PASSENGER SIDE RIM WAS FRACTURED AND THAT THE WHEEL WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT SHORTLY THEREAFTER, THE TIRE PRESSURE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN STATED TO THE CONTACT THAT THE FRONT DRIVER SIDE RIM WAS FRACTURED. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 105,000. UPDATED 03/14/12*LJ
Feb 03, 2012
+ 2 more complaints for this component
STEERING,SERVICE BRAKES
5 complaints
TL* THE CONTACT OWNS A 2008 FORD F-350. WHILE DRIVING 65 MPH AND ATTEMPTED TO EXIT THE HIGHWAY, THE STEERING WHEEL SEIZED AND THE BRAKE PEDAL WAS DEPRESSED, BUT THE BRAKES FAILED TO ENGAGE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE DEALER WAS NOT CALLED FOR DIAGNOSTIC TESTING OR REPAIRS. THE CONTACT STATED THAT THE FAILURE RECURRED. THE CONTACT CALLED THE MANUFACTURER, BUT THERE WAS NO RESPONSE. THE FAILURE MILEAGE WAS APPROXIMATELY 104,000.
Apr 16, 2018
TL* THE CONTACT OWNS A 2008 FORD F-350. WHILE DRIVING APPROXIMATELY 55 MPH, THE STEERING WHEEL AND BRAKING ABILITY SEIZED AND BECAME DIFFICULT TO MANEUVER WITHOUT WARNING. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 118,000.
Jan 05, 2017
TL* THE CONTACT OWNS A 2008 FORD F-350. WHILE DRIVING APPROXIMATELY 60 MPH, THE STEERING AND BRAKING ABILITY SEIZED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED BY THE DEALER OR AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 129,000.
May 26, 2015
I WAS DRIVING AT 20 MPH WHEN THE POWER STEERING DID NOT WORK, I WENT TO BRAKE AND IT DIDN'T BRAKE FOR AT LEAST 20 FT. GOOD THING NO ONE WAS IN FRONT OF ME. I TOOK IT HOME AND NOW IS NOT DRIVABLE , I CALLED FORD SEVERAL TIMES AND THEY SAID THEY CAN NOT DO ANYTHING FOR ME.I HAVE A $48,000.00 LEMON ROTTING IN MY DRIVEWAY. *TR
May 21, 2014
I WAS SLOWING DOWN TO MAKE A LEFT HAND TURN AND I COMPLETELY LOST THE ABILITY TO STEER. I COULD NOT BUDGE THE WHEEL AT ALL. MY BRAKES STILL WORKED, BUT IT DIDN'T FEEL 100%. IT HAS HAPPENED AT LEAST 10-15 TIMES IN THE LAST YEAR. WHEN IT HAPPENS, I CAN SHIFT THE TRUCK INTO NEUTRAL AND REV THE ENGINE AND I'LL GET MY STEERING BACK. ALSO, IF I SHIFT INTO NEUTRAL AND TURN THE TRUCK OFF AND BACK ON AGAIN, THE STEERING WILL WORK. THE ONLY TIME IT HAPPENS IS WHEN I'M SLOWING DOWN FROM HIGHWAY SPEEDS, 55+ MPH. IT HAS HAPPENED WHEN TOWING ALSO. THIS IS MY FATHER TRUCK, BUT I USE IT FOR THE FAMILY BUSINESS. *TR
Jun 04, 2013
POWER TRAIN
5 complaints
TL* THE CONTACT OWNS A 2008 FORD F-350 SD. WHILE DRIVING APPROXIMATELY 10 MPH, THE CONTACT HEARD AN ABNORMAL NOISE FROM THE FRONT OF THE VEHICLE. IN ADDITION, THE VEHICLE WENT INTO LIMP MODE. A LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT TO CALL NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 212,425. THE VIN WAS NOT AVAILABLE.
Jan 24, 2018
I HAVE A 2008 350 SUPER DUTY FORD TRUCK. I HAVE ABOUT 35,000 MILES ON THE TRUCK AND IN THOSE MILES I HAVE HAD ABOUT A DOZEN INCIDENTS WHERE THE TRUCKS AUTOMATIC TRANSMISSION DID NOT START FROM A DEAD STOP IN 1ST. GEAR. IN STEAD IT MUST HAVE STARTED IN 3RD. OR 4TH GEAR RESULTING IN WHAT WOULD BE A VERY UNDERPOWERED START. I WOULD PRESS THE ACCELERATOR TO THE FLOOR WHICH WOULD RESULT IN THE TRANSMISSION DOWN SHIFTING AND THE WHEELS SPINNING EVEN WHEN PULLING A 5TH WHEEL TRAILER. TWICE, WHILE EMPTY, I NEARLY HAD AN ACCIDENT WHEN I NEEDED A RAPID RESPONSE TO ENTER TRAFFIC. THE LAST TIME THIS HAPPENED WAS 8/25/2010. WHEN I HAVE TAKEN THIS COMPLAINT TO A FORD DEALERSHIP, THEY SAY THEY CAN NOT FIND ANY CODES, HOWEVER THE LAST TIME THE DEALER DID A COMPUTER UPDATE ON THE TRUCK AND THAT WAS ABOUT 10 MONTHS AGO AND I THOUGHT THE PROBLEM WAS SOLVED. I MET ANOTHER PERSON WITH THE SAME POWER TRAIN AS MINE WHO HAD THE SAME PROBLEM, FINALLY HIS TRANSMISSION WENT OUT AND HAD TO BE REPLACED. I WOULD LIKE TO HAVE YOU INVESTIGATE THIS ISSUE, IT MAY SAVE A LIFE. *TR
Aug 27, 2010
I WAS NOTIFIED BY FORD THAT MY 2008 F-350 6.4 DIESEL PICKUP HAD TWO RECALL NOTICES TO BE PERFORMED. ON 1.29.08 I TOOK THE TRUCK TO CAPISTRANO FORD AND THEY PERFORMED RECALL 08B06 AND RECALL 08B07. SINCE THEN THE AUTOMATIC TRANSMISSION HAS NOT PERFORMED THE SAME. I PULL A FIFTH WHEEL TRAILER. THE DRY WEIGHT OF THE TRAILER IS ABOUT 9000LBS. WHEN GOING DOWNHILL THE AUTOMATIC TRANSMISSION NO LONGER DOWNSHIFTS TO ASSIST IN BRAKING AND DOWNHILL SPEED CONTROL. THE TRANSMISSION IS EQUIPPED WITH A TOW/ HAUL SETTING ON THE END OF THE SHIFT LEVER. BEFORE THE RECALL THIS FEATURE WORKED GREAT. AS YOU START DOWN A HILL, TAKING YOUR FOOT OFF THE GAS THE TRUCK WILL COAST AND THEN BEGIN TO PICK UP SPEED. WHEN THE TRANSMISSION SENSED THE INCREASE IN SPEED WHILE COASTING, THE TRANSMISSION WOULD AUTOMATICALLY DOWNSHIFT. IT WOULD DO THIS AT ANY SPEED. AFTER THE RECALL, THE TRANSMISSION WILL NOT DOWNSHIFT UNTIL LONG AFTER IT HAS ANY AFFECT ON BRAKING OR SPEED CONTROL. WHILE BRAKING, SOMETIMES HARD IF IT IS A STEEP HILL, THE TRANSMISSION WILL DOWNSHIFT AND THE TRUCK WILL SHUTTER. IT IS A SHORT BURST THAT IS VERY NOTICEABLE AND OBVIOUSLY NOT NORMAL.THE SHUTTER NEVER HAPPENED BEFORE THE RECALL. I HAVE TAKEN IN BACK TO FORD TWICE AND THEY SAY THAT THE TRANSMISSION CONTROL MODULE (TCM) WAS REPROGRAMMED AS PART OF RECALL 08B07 BUT THEY CAN NOT CHANGE IT BACK TO THE ORIGINAL PROGRAM. IN SHORT, FORD WILL NOT DO ANYTHING ABOUT THIS. THE OPERATIONAL SAFETY OF THE VEHICLE, WHILE TOWING LOADS THAT THE TRUCK IS DESIGNED TO TOW, HAS BEEN COMPROMISED. FORD SAYS THEY CAN NOT DO ANYTHING ABOUT IT. IS ANYONE ELSE HAVING THIS PROBLEM? ACCORDING TO FORD THIS COMPLAINT HAS NOT BEEN MADE. IF I'M THE ONLY ONE HAVING THE PROBLEM, THEN FORD SHOULD FIX MY TRUCK. *TR
Jun 19, 2009
TRUCK CAUGHT ON FIRE WHILE DRIVEING DOWN RAOD
Oct 30, 2008
WHEN TRUCK GOES INTO REGENERATION MODE(ON DRIVE OR REVERSE) IT IS SOMETIMES VERY HARD TO KEEP IT UNDER CONTROL...IT WANTS TO ACCELERATE--- NORMALLY IT GOES UP TO 1200 TO 1300 RPM BUT ON 2 OR 3 TIMES ITS GONE UP TO 1500, 1 TIME IT WENT UP TO 2300 RPM ( THAT'S NOT SAVE )--------2 TIMES ENGINE LOST POWER WHILE DRIVING AT 65-70 MPH...TRUCK MAKES A LOUD METAL TO METAL NOISE WHEN YOU GO FROM DRIVE TO REVERSE AND WHEN YOU START MOVING... *TR
Mar 12, 2008
FUEL SYSTEM, DIESEL
5 complaints
TL* THE CONTACT OWNS A 2008 FORD F350. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE VEHICLE STALLED AND THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSE THAT THE WIRE HARNESS WAS DAMAGED AND CAUSED THE FUEL PUMP TO SHORT OUT. AS A RESULT, THE WIRE HARNESS AND THE FUEL PUMP NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE NO LONGER UNDER WARRANTY. THE FAILURE MILEAGE WAS 41,200. UPDATED 11/13/12 *CN
Sep 10, 2012
2008 F350 FORD TRUCK, BAD HIGH PRESSURE FUEL PUMP. FORD REFUSING TO SUPPORT THEIR WARRANTY. RUNNING ROUGH, WITH NO HIGH END POWER. STALLED WHILE TRYING TO PULL OUT INTO BUSY TRAFFIC. SLOWED TO 20MPH IN MIDDLE OF HIGHWAY TRAFFIC. FORD DEALER ANALYZED TROUBLE TO HIGH PRESSURE FUEL PUMP WHICH SHOULD BE COVERED BY FORD 100,000 MILES/5YR WARRANTY. FORD WILL NOT SUPPORT THEIR WARRANTY DUE TO RUST FOUND IN FUEL TANK. RUST IN THE SYSTEM WOULD BE A FAILURE OF FORDS FILTERING SYSTEM / DESIGN WHICH SHOULD BE COVERED BY WARRANTY. COST OF REPAIR IS $8500. *TR
Apr 29, 2012
TL* THE CONTACT OWNS A 2008 FORD F-350 SD. THE CONTACT STATED THAT WHILE HAVING THE PCM REPROGRAMMED UNDER NHTSA CAMPAIGN I.D. NUMBER: 07V139000 (POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM), THE DEALER NOTICED THAT THE FUEL TANK WAS DELAMINATING. THE DELAMINATING FUEL TANK COULD CAUSE CLOGGING PROBLEMS IN THE FUEL INJECTORS. THE DEALER SUGGESTED THAT THE FUEL TANK BE REPLACED. THE DEALER REPLACED THE FUEL TANK. THE CONTACT STATED THE FUEL TANK SHOULD NOT HAVE DELAMINATED IN TWO YEAR OF OWNING THE VEHICLE AND WAS A SERIOUS SAFETY ISSUE. THE FAILURE MILEAGE WAS 13,000.
Jun 03, 2011
I HAVE 2008 FORD F350 XLT 4X4 SRW DIESEL JUST OVER A YEAR AND WHAT HAVE HAPPENED NOW IS THAT ON 08/02/1010 WHILE I WAS DRIVING THERE WERE NOISES FROM THE ENGINE ALSO SOOO MUCH OF WHITE SMOKE COMING OUT FROM EXHAUST PIPE AND THEN THE TRUCK JUST FAILED ON THE HIGHWAY AND WAS TOWED TO THE CLOSEST FORD DEALER LOCATION AFTER A WEEK SITTING THERE SERVICE PEOPLE FROM DEALERSHIP SAID THAT WAS OIL AND FUEL SPILLAGE ALL OVER THE FILTER AND THE ENGINE ETC.. BUT THEY DIDN'T DO ANYTHING TO FIND OUT WHAT WAS CAUSING IT AND I ENDED UP WITH THE BILL FOR IT AN HOUR LATER WHEN I TOOK IT THE TRUCK IT HAVE HAPPENED AGAIN THIS TIME I HAVE TAKEN THE TRUCK TO ANOTHER FORD DEALERSHIP AFTER FEW DAYS THEY SAID THAT WAS SOMETHING MINOR AND THEY GAVE ME THE TRUCK WHEN I JUST LEFT THEIR SHOP IN THE EVENING SAME PROBLEM SO MUCH SMOKE THAT YOU COULDN'T SEE ANYTHING THE SMOKE WAS CHOKING ME SO NOW AGAIN THE TRUCK IS IN THE DEALERSHIP SERVICE BUT THEY NOW POINTING FUEL INJECTORS AND AGAIN THEY WANT ME TO PAY FOR OIL AND FUEL SPILLAGE SO THAT THEY AGAIN GOING TO CHANGE OIL AND FILTER BUT THEY NOT WORKING ON FIXING THE REAL PROBLEM! AT THIS MOMENT I'M AFRAID TO DRIVE THIS TRUCK BECAUSE OF THE FUEL SPILLAGE I KNOW IT CAN RESULT IN A FIRE AND IS NOT SAFE TO DRIVE THIS TRUCK WITH SO MUCH SMOKE COMING OUT FROM EXHAUST FILTER
Aug 20, 2010
3 TIMES IN THE LAST 6 MONTHS MY FORD F350 HAS SHUT DOWN WHILE I AM DRIVING, IT LOCKS ME OUT SO I CAN'T EVEN TURN THE ENGINE OVER AND I HAVE TO TRY TO COAST TO A SAFE PLACE OUT OF TRAFFIC. ALL 3 TIMES THE FUEL GAUGE READS OVER 50 MILES TO EMPTY, THE LAST TIME IT READ 140 MILES TO EMPTY. THE FUEL LINES ARE SUCKING IN AIR, I GET HIGH AND LOW PRESSURE CODES, I ADD MORE FUEL(DEISEL) AND THEN HAVE TO BLEED ALL OF THE LINES OF AIR AND PRIME THE PUMPS. I HAVE TO DO THIS ON THE SIDE OF THE ROAD OR IN A PARKING LOT IF I AM FORTUNATE ENOUGH TO MAKE IT THAT FAR. I PULLED THE TANK AND PULLED THE FUEL SENDING UNIT OUT, UPON CLEANING OUT THE TANK FOUND A PLUNGER ROLLING AROUND. THIS PLUNGER GOES IN THE FUEL SENDING UNIT, CLOSING A VALVE THAT SUCKS FUEL IF THE MAIN SUCTION GETS CLOGGED. IT IS ABOUT 2 INCHES HIGHER THAN THE MAIN SUCTION. BECAUSE THE PLUNGER HAS FALLEN OUT, THIS IS WHERE IT IS SUCKING FUEL FROM, WHICH CAUSES IT TO SUCK AIR WHEN THERE IS IN FACT STILL FUEL IN THE TANK. I CALLED FORD SERVICE AND WAS TOLD THEY REPLACE THESE UNITS ALL OF THE TIME, IT IS A MANUFACTURERS DEFECT BUT NOT COVERED IF YOUR VEHICLE IS OUT OF THE 36K WARRANTY, WHEN THIS MOST COMMONLY HAPPENS. THE LAST TIME THIS HAPPENED A FRIEND PULLED MY TRUCK INTO A PARKING LOT,WHILE HE WAS PULLING ME IN, THERE WAS ANOTHER FORD TRUCK BEING PULLED IN AFTER RUNNING OUT OF FUEL WHILE THE GAUGE STILL READ 50 MILES TO EMPTY. THIS IS VERY DANGEROUS WHEN IT HAPPENS ON THE INTERSTATE, YOU HAVE NO POWER STEERING AT THIS POINT AND CAN NOT EASILY HANDLE THE VEHICLE DUE TO THE WEIGHT OF THIS VEHICLE. MY WIFE WOULD NEVER BE ABLE TO HANDLE THE VEHICLE IF THIS HAPPENS. I WON'T LET HER DRIVE THE TRUCK DUE TO THIS. *TR
Feb 12, 2010
ENGINE,FUEL/PROPULSION SYSTEM
4 complaints
Vehicle died while driving on the freeway. Towed to the local Ford who did a diagnostic and test they found that the engine is completely done with as there was an engine oil overfill, and it filled the CAC system and melted cylinder eight piston. they’re saying that they will need to replace the entire engine and HP fuel pump in order to repair and I see many others have experienced this same problem.
May 14, 2025
TRUCK WAS TAKEN TO FORD DEALER AND DIAGNOSED WITH LOW PRESSURE FUEL PUMP AND HIGH PRESSURE FUEL PUMP OUT.PRIOR TO THIS WHITE SMOKE ROLLED OUT OF EXHAUST WHILE DRIVING ON HIGHWAY AND ENGINE SHUT OFF.TRUCK WAA TOWED TO DEALER WITH ABOVE FINDINGS.FORD DIESEL MECHANIC STATED SEVERAL ISSUES WITH HIGH AND LOW PRESSURE FUEL PUMPS ON THESE MODELS.PLEASE LOOK INTO THIS.ESTIMATED COST IS 13,000 DOLLARS TO FIX.
Sep 06, 2017
SHORTLY AFTER THE TRUCK IS UP TO OPERATING TEMPERATURE A CONSTANT PLUME OF WHITE SMOKE CONTINUOUSLY EMITS FROM THE EXHAUST. FUEL ECONOMY HAS HAD A SUBSTANTIAL LOSS. DURING LOWER LEVELS (1/4 OR LOWER LEVELS OF DIESEL) OF FUEL CAPACITY THE ENGINE WILL STALL AND DIE UPON TAKE OFF. ATTEMPTING TO RESTART AFTERWARDS WAS VERY DIFFICULT. DURING THIS PROCESS A "WRENCH" APPEARS ON THE DASH AND THAT'S ABOUT IT. I HAVE NOT CHECKED "CODES" YET AND THE CHECK ENGINE LITE IN ON.
May 11, 2016
WAS DRIVING AT APPROXIMATELY 40MP WHEN THE ENGINE JUST STOPPED AND LOST POWER. THIS HAPPENED ON 2 MORE OCCASIONS. ONCE WHILE PULLING OUT ONTO A BUSY STREET, AND WAS ALMOST HIT BY ONCOMING TRAFFIC. CANNOT RISK INJURY, SO TOOK IT RIGHT TO A REPUTABLE LOCAL DIESEL MECHANIC. DIESEL MECHANIC STATES THAT ENTIRE FUEL SYSTEM MUST BE REPLACED. FAULTY HI PRESSURE FUEL PUMP DISINTEGRATED AND SENT METAL THRU FUEL SYSTEM. THIS WILL COST $8000 TO FIX. WAS TOLD THIS WAS THE FIRST YEAR "BUG" FOR A NEW DESIGN. FORD WILL NOT REPLACE PARTS OR WARRANTY THIS. COMMON ON THIS MODEL, BUT DEFINITELY A SAFETY HAZARD, AS THE TRUCK MAY OR MAY NOT STALL WHEN GIVING GAS. IT IS UNPREDICTABLE. *TR
Jan 17, 2014
SERVICE BRAKES
4 complaints
CRUSE CONTROL SWITCH ON THE BRAKE MASTER CYLINDER DISINTEGRATED, CAUSING IMMEDIATE LOSS OF BRAKE FLUID AND BRAKING. SWITCH BODY APPEARED RUSTY, WHILE THE SWITCH NEXT TO IT ON THE MASTER CYLINDER DID NOT. VEHICLE IN MOTION, DESCENDING DRIVEWAY WHEN BRAKE PEDAL WENT TO THE FLOOR AND ALL BRAKING ACTION WAS LOST. VEHICLE STOPPED VIA EMERGENCY BRAKE.
Jan 19, 2020
I WAS IN MY DRIVEWAY AND STEPPED ON THE BRAKE PEDAL TO PUT THE TRUCK IN REVERSE AND I HEARD A LOUD 'POP' WHICH FELT LIKE THE BRAKE PEDAL BROKE AND THEN IT SANK TO THE FLOOR, I POPPED THE HOOD AND SAW BRAKE FLUID DRIPPING FROM THE BOTTOM OF THE BRAKE MASTER CYLINDER. THIS PART---"SWITCH ASSY - FORD PART-SW6349 (9F924)" HAD BLOWN OUT THE PLASTIC CONNECTOR WHILE THE METAL CASING WAS STILL ATTACHED TO THE BOTTOM OF THE MASTER CYLINDER. THIS WILL LEAVE YOU WITH NO BRAKES. IF IT HAPPENED ON THE ROAD IN TRAFFIC IT COULD BE DEADLY.
Jun 13, 2019
TL* THE CONTACT OWNS A 2008 FORD F-350. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE VEERED TO THE RIGHT CAUSING THE CONTACT TO ALMOST CRASH INTO A GUARD RAIL. THE CONTACT DISCOVERED SMOKE ENTERING FROM A PASSENGER SIDE WHEEL. THE CONTACT STATED THAT THE PASSENGER BRAKE DISC WAS RED FROM THE HEAT AND EMITTED SMOKE. THE CONTACT ALSO STATED THAT THE SAME FAILURE OCCURRED SIX TIMES ON DIFFERENT WHEELS. THE CONTACT HAD TO WAIT FOR THE WHEELS TO COOL DOWN IN ORDER FOR THE VEHICLE TO RETURN TO NORMAL. THE VEHICLE WAS DRIVEN TO THE DEALER SIX TIMES AND THEY WERE NOT ABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT MENTIONED THAT THE BRAKE SYSTEM WAS REPAIRED FOUR TIMES. THE APPROXIMATE FAILURE MILEAGE WAS 35,000.
Sep 21, 2015
TL* THE CONTACT OWNS A 2008 FORD F-350. THE CONTACT STATED THAT THE BRAKE SYSTEM FAILED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THE BRAKES, CALIPERS AND ROTORS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE PROBLEM PERSISTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 20,000.
Aug 19, 2014
POWER TRAIN,ENGINE
3 complaints
TL* THE CONTACT OWNS A 2008 FORD F-350. THE CONTACT STATED THAT THE VEHICLE SHOOK VIOLENTLY AFTER GOING OVER A SPEED BUMP. THE VEHICLE WAS TAKEN TO BEACH FORD LOCATED AT (2717 VIRGINIA BEACH BLVD, VIRGINIA BEACH, VA 23452) HOWEVER, THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO INFORMED THE CONTACT THE FAILURE WAS KNOWN AS THE DEATH WOBBLE. AN UNKNOWN REPAIR WAS PERFORMED HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO BEACH FORD TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE TURBO CHARGER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 20,000.
Jul 02, 2020
I NOTICED A PLUM OF WHITE SMOKE OUT THE TAIL PIPE. THAT INDICATED STEAM, WATER IN THE SYSTEM TO ME. ALL THE GAUGES WERE NORMAL AND I STOPPED THE VEHICLE AND CHECKED THE FLUID LEVELS. NO OBVIOUS PROBLEM. I CALLED MY LOCAL FORD DEALERSHIP AND THEY COULD NOT GET IT IN FOR 36 HOURS. I DROVE IT .4 MILES HOME AND PARKED IT. AT THE APPOINTED TIME I DROVE TO NORTH COUNTRY FORD. IT TOOK THEM ANOTHER DAY TO FIND THE DIESEL MECHANIC WHO COULD WORK ON THE VEHICLE. 24 HOURS LATER I AM TOLD THE ENGINE IS BLOWN; FLUID GOT INTO THE MANIFOLD AND WAS SUCKED INTO THE # 3 CYLINDER. DEPENDING ON THE AMOUNT OF PARTS THAT COULD BE SALVAGED THE COST OF REPLACEMENT COULD EXCEED $ 12,000. THIS VEHICLE HAS 95,000 MILES ON IT. IT HAS HAD TOW OTHER INCIDENTS WITH THE ENGINE AND DRIVE TRAIN: IN DECEMBER OF LAST YEAR, IN PREPARATION FOR A TRIP TO ARIZONA I HAD THE TRANSMISSION SERVICED. ABOUT 1400 MILES LATER THE TRANSMISSION BEGAN TO SLIP WHEN WE ENCOUNTERED ANY HILLS OR MOUNTAINS. I PARKED THE TRAILER AND TOOK THE TUCK TO CASSA FORD. THEY HAD THE TRUCK FOR 4 DAYS AND $ 1600.00 WORTH OF REPAIRS. I ASKED IF ANYTHING DONE AT THE TIME IT WAS SERVICE OR THE DRIVING FROM THE FIRST SIGN OF TROUBLE HAD CAUSED OR EXACERBATED THE PROBLEM. THEY SAID NO, IT WAS A PUMP PROBLEM. IN 2011, IT BEGAN TO BLOW BLACK SMOKE OUT THE TAILPIPE; THE DASH SCREEN INDICATED IT WAS CLEANING THE EXHAUST. WITHIN 5 MINUTES THE ENGINE SPUTTERED AND DIED. I CALLED FORD I WAS TOLD TO WAIT AN HOUR AND TRY TO RESTART THE VEHICLE; GIVE THE ENGINE AN OPPORTUNITY TO 'RE-SET' ITSELF. THAT DIDN'T WORK! A TOW WAS SENT AND THE VEHICLE TOWED TO NELSON FORD DEALER IN FERGUS FALLS, MINNESOTA. IT WAS A FAILED EGR VALVE. THE REPAIR WAS COVERED UNDER WARRANTY.
Nov 26, 2016
FORD F350 WITH 6.4L DIESEL HAD CHECK ENGINE LIGHT (CEL) ILLUMINATE WHILE DRIVING. ENGINE IMMEDIATELY SLOWED TO IDLE (800RPM) AND WOULD NOT RESPOND TO THROTTLE INPUTS. WAS NOT ABLE TO CLEAR ROADWAY AND BLOCKED TRAFFIC ON BUSY URBAN ROAD. DEALER WAS "NOT ABLE TO FIND ANYTHING WRONG", YET "PERFORMED CALIBRATION UPDATE ON PCM". I WAS INFORMED "THIS NEEDS TO BE DONE AS VEHICLE AGES AND SENSORS WEAR." REVIEWED OWNERS MANUAL AND DID NOT LOCATED MAINTENANCE INTERVAL FOR "CALIBRATION UPDATES TO PCM." I AM CERTAIN THIS IS AN INHERENT PCM SOFTWARE CODE ERROR LEADING TO COMPLETE LOSS OF ENGINE OPERATION. A DANGEROUS SITUATION ON CONGESTED ROADWAYS. *TR
Nov 07, 2012
FUEL/PROPULSION SYSTEM
3 complaints
THE HIGH PRESSURE FUEL PUMP FAILED, CAUSING THE TRUCK TO LOSE POWER WHILE MERGING ONTO THE INTERSTATE. OUR VEHICLE DID NOT DIE COMPLETELY, AS I'VE HEARD MOST DO. IF WE HAD BEEN HAULING OUR RV, IT COULD HAVE BEEN CATASTOPHIC IN THAT SITUATION. FORD HAS HAD THESE PUMPS RECALLED ON OTHER VEHICLES (A VAN?), BUT BECAUSE THE REPAIR IS COSTLY, I BELIEVE THAT FORD MAY NOT WANT TO RECALL THESE VEHICLES. THE WORST PART OF IT IS THAT ANYONE THAT OWNS AN F350 BUYS IT TO HAUL SOMETHING. IN OUR CASE, A 13000 POUND RV. IF WE LOST POWER STEERING AND BRAKES IN THE MOUNTAINS OF COLORADO AND WYOMING, IT WOULD NOT BE GOOD. EVERY MECHANIC WE TALKED TO ABOUT THIS SEEMS TO FEEL THIS IS A COMMON PROBLEM ON THE F350 6.4L POWERSTROKE
Sep 19, 2016
I RECENTLY PURCHASED A 2008 FORD F350 DIESEL CREW CAB PICKUP FROM HAYFORD FORD IN ISANTI MN. I HAVE DRIVEN THE VEHICLE A TOTAL OF 1500 MILES SINCE I PURCHASED IT. THE VEHICLE HAS BEEN IN THE SHOP MORE THAN 20 DAYS SINCE I PURCHASED IT. THEY NOW SAY I WILL HAVE A BILL OF $8000 DOLLARS TO REPAIR THE CONTAMINATED DIESEL FUEL SYSTEM. I UNDERSTAND THAT THERE HAS BEEN A FUEL TANK DELAMINATION ISSUE ON THESE VEHICLES THAT CAUSES THIS PROBLEM. THAT CAN LEAD TO A STALLING OF THE ENGINE IF NOT DETECTED PRIOR TO TOTAL FAILURE. FORD WILL NOT EVEN HONOR THE WARRANTY I PURCHASED FROM THEM. I NOTICED THE INCREASE IN ENGINE OIL VOLUME PRIOR TO ANY FAILURE WHICH LED FORD TO DIAGNOSE A FUEL PUMP FAILURE PRIOR TO ENGINE FAILURE. I UNDERSTAND THERE HAVE BEEN FAILURES WHILE THE VEHICLES ARE IN MOTION, WHICH WOULD CAUSE THE POSSIBILITY OF SERIOUS ACCIDENTS.
Aug 27, 2016
GETTING ON FREEWAY AND TRYING TO REACH AND MAINTAIN POSTED SPEED LIMIT. VEHICLE STARTED SPUTTERING THEN CHECK ENGINE LIGHT CAME ON. I COULD NOT SAFELY MAINTAIN MY SPEED SO I HAD TO PUT FLASHER ON AND PULL OFF THE ROAD. I QUICKLY FOUND OUT THAT THE VEHICLE WENT INTO TO LIMP HOME MODE SO WITH MY FLASHERS ON I PROCEEDED TO HEAD HOME WHICH WAS 40 MILES AWAY. I INDEED LIMPED MY VEHICLE HOME AS I COULD NOT MAINTAIN ANY POSTED SPEED LIMIT AND CREATED WHAT I THOUGHT WAS AN UNSAFE CONDITION FOR OTHER DRIVERS AS THEY WERE TRYING TO PASS AND GET AROUND ME. AFTER MAKING IT HOME I FOUND OUT THAT THERE IS A KNOWN MANUFACTURE DEFECT WITH A PUBLICATION DATE OF APRIL 27, 2011 TSB 11-4-22 6.4L LACKS POWER-DTC P0088. I PULLED MY ENGINE CODES AND I INDEED HAD THE P0088 CODE WHICH IS FUEL RAIL PRESSURE TOO HIGH. I CALLED MY LOCAL FORD DEALERSHIP TO FIND OUT IF THERE WAS A RECALL FOR THE KNOWN MANUFACTURE DEFECT. THE GENTLEMAN PUT MY VIN# IN AND TOLD ME THERE WAS NO RECALL FOR THAT KNOWN DEFECT FROM FORD. I'VE DONE MY RESEARCH AND THERE ARE MANY PEOPLE OUT THERE WITH THIS SAME PROBLEM. FORD HAS ADMITTED TO THE KNOWN MANUFACTURE DEFECT BY CREATING THE TSB WITH THE PUBLICATION DATE OF APRIL 27, 2011
May 22, 2015
ELECTRICAL SYSTEM
3 complaints
TL* THE CONTACT OWNS A 2008 FORD F-350. THE CONTACT STATED THAT THE BATTERY WARNING LIGHT ILLUMINATED AND THE CONTACT DISCOVERED SMOKE COMING FROM UNDER THE HOOD. THE CONTACT ALSO MENTIONED THAT ONCE THE HOOD WAS OPENED, THE ALTERNATOR CAUGHT ON FIRE. THE CONTACT EXTINGUISHED THE FIRE. THE POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE ALTERNATOR WAS CYCLING MORE THAN DESIGNED BECAUSE THE BATTERY WAS NOT FUNCTIONING PROPERLY CAUSING THE FIRE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 81,000.
Jan 16, 2015
EXHAUST GAS TEMP SENSOR ISSUE: DRIVING AT HIGHWAY SPEED, THANK GOD I WASN'T TOWING MY 5TH WHEEL. GOT THE MESSAGE ON THE DASH "STOP SAFELY NOW" AND 10 SECONDS LATER THE TRUCK SHUT ITSELF OFF. THIS IS A SERIOUS SAFETY HAZARD. IF I HAD BEEN TOWING THE TRAILER ON A HILL I DREAD TO THINK WHAT WOULD HAVE HAPPENED. TOWED THE VEHICLE TO ONE FORD DEALER, THEY COULDN'T DIAGNOSE EVEN THOUGH I FOUND THE PROBLEM ONLINE ( MANY F350 OWNERS HAVE HAD THE EXACT SAME EXPERIENCE) AND THEY TOLD ME TO PICK IT UP THE NEXT DAY. I DID THAT, AND ABOUT A HALF HOUR DOWN THE ROAD IT HAPPENED AGAIN. TOWED TO A DIFFERENT DEALERSHIP, THEY REPLACED ONE OF THE 4 EXHAUST GAS TEMP SENSORS AND AFTER AN ABSURD $500 REPAIR BILL FOR AN $89 PART I WAS ON MY WAY. FORD HAS OBVIOUSLY KNOWN THIS IS A PROBLEM AS THEY HAVE CHANGED THEIR PART NUMBER ON THESE SENSORS - THEY DID SOME SORT OF A REDESIGN REQUIRING A NEW PART NUMBER. I NOW CARRY A SPARE SENSOR WITH ME AT ALL TIMES AS WELL AS THE CORRECT SIZE WRENCH TO REPLACE IT. THIS SHOULD ABSOLUTELY BE A RECALL ISSUE SINCE IT IS BOTH A SERIOUS SAFETY ISSUE AS WELL AS SOMETHING THAT MANY OF US HAVE HAD. A SIMPLE ONLINE SEARCH FINDS MANY PEOPLE WITH THE SAME STORY. I DID CALL FORD CUSTOMER SERVICE, ABSOLUTELY NO ACTION ON THEIR PART. THE OLD ADAGE OF FORD = FOUND ON ROADSIDE DEAD OR FIX OR REPAIR DAILY WAS DEFINITELY TRUE FOR ME. I DO HAVE THE FORD CUSTOMER CARE CASE NUMBER SOMEWHERE IF YOU NEED THAT... *TR
Nov 06, 2014
THIS TRUCK HAS HAD 3 SMART JUNTION BOXES REPLACED IN THE LAST 3 YEARS IT EFFECTS THE FRONT TURN SIGNALS AND FLASHERS. IT IS A SAFETY PROBLEM SINCE WE ARE A DPW AND THE TRUCK SITS WITH ITS FLASHERS ON FOR OUR WORKERS. *TR
Aug 12, 2013
ENGINE AND ENGINE COOLING,FUEL SYSTEM, DIESEL
3 complaints
2008 FORD F350 SUPER DUTY. ATTORNEY REPRESENTING CONSUMER WRITES IN REGARDS TO ENGINE PROBLEMS, EGR VALVES AND HIGH PRESSURE FUEL PUMPS FAILURE THAT MANUFACTURER HAS FAILED AND REFUSED TO REPAIR. *SMD
Jun 19, 2013
LOSES POWER WHILE DRIVING CAN NOT GET ANY SPEED ALMOST GOT HIT ON INTERSTATE SINCE IT DROPPED SPEED FROM 70 TO 40 FUEL PUMP REPLACED STILL AT DEALERS HAS BEEN THERE FOR 3 WEEKS HAD IT IN THE SHOP A FEW MONTHS AGO FOR COOLING SYSTEM THIS IS SUPPOSED TO BE A HEAVY DUTY TRUCK THERE IS A NUMBER OF PROBLEMS WITH THESE TRUCKS . WITH 73 BULLETINS ON THEM I THINK IT IS A SAFETY ISSUE !!!!!!!!! *TR
Jul 31, 2010
2008 FORD 350 DIESEL PICK UP. CONSUMER EXPRESSES DISCONTENT WITH FORD MOTOR COMPANY *TGW THE CONSUMER STATED THE ENGINE LOCKED UP ON HIS VEHICLE WITH ONLY 19,300 MILES. THE CONSUMER FOUND A TSB REGARDING SYMPTOMS OF WATER IN THE FUEL TANK VENT AREA. THE CONSUMER STATED IT SEEMED THAT FORD WAS AWARE OF THE POSSIBILITY OF WATER ENTERING THE FUEL TANK VENT AREA DUE TO SNOW AND ICE BUILD-UP.
Jul 14, 2010
VEHICLE SPEED CONTROL
3 complaints
TL* THE CONTACT OWNS A 2008 FORD F-350 SD. THE CONTACT STATED THAT AFTER SHIFTING INTO GEAR, THE VEHICLE ACCELERATED TO APPROXIMATELY 30 MPH. THE CONTACT WAS UNABLE TO CONTROL THE MALFUNCTION AND CRASHED INTO SEVERAL TREES. THE CONTACT DID NOT SUSTAIN ANY INJURIES. THE POLICE WERE CONTACTED A REPORT WAS FILED. THE VEHICLE WAS LATER TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DEEMED AS DESTROYED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 134,336. *TR
Apr 01, 2013
2008 FORD 350 SD ACCELERATED 2 DIFFERENT TIMES AT VERY HIGH SPEED. COULD NOT STOP IT EITHER TIME. HAD TOO PUT IT INTO PARK TO STOP AND SMOKE FILLED THE CAB AND WAS ROLLING OUT. MECHANIC IN . SAID IT WAS THE THIRD ONE TOO COME IN AND THE SECOND HAD BEEN IN ACCIDENT. SAID THEY DON'T MAKE THE SOFTWARE TOO FIX THIS PROBLEM. APPROXIMATELY 5,000 MILES. FORD MOTOR CREDIT TOOK TRUCK AFTER PAYING $38,000 ON IT AND ARE GOING TOO AUCTION IT OFF IN SPOKANE WASH. I AM REALLY CONCERNED FOR THE BUYER. *TR
Feb 18, 2010
TL*THE CONTACT OWNS A 2008 FORD F-350 SUPERDUTY. THE CONTACT STATED THAT THE VEHICLE WOULD SURGE INTERMITTENTLY. WHEN HE WOULD DEPRESS THE BRAKE PEDAL IN AN ATTEMPT TO STOP THE VEHICLE, THE RPM'S WOULD REV UP TREMENDOUSLY AND THE VEHICLE WOULD SURGE LIKE A ROCKET. HE WOULD HAVE TO KEEP THE BRAKE PEDAL DEPRESSED WHILE THE VEHICLE CONTINUED TO "CRAWL" AND HE WAS ABLE TO TURN OFF THE IGNITION. THE CONTACT STATED THAT THE FAILURE ONLY SEEMED TO OCCUR WHEN COMING TO A STOP. HE NOTIFIED THE DEALER OF THE ISSUE AND HAD THE VEHICLE INSPECTED; HOWEVER, THEY FOUND NO FAILURES AND STATED THAT THERE WERE NO RECALLS AVAILABLE. A COMPLAINT WAS FILED WITH THE MANUFACTURER. THE CURRENT MILEAGE WAS APPROXIMATELY 25,500 AND FAILURE MILEAGE WAS APPROXIMATELY 24,000.
Apr 01, 2009
FUEL SYSTEM, GASOLINE
3 complaints
TL* THE CONTACT OWNS A 2008 FORD F-350 SD. THE CONTACT STATED THAT WHILE ATTEMPTING TO ASCEND AN INCLINE, THE VEHICLE LOST POWER, MAKING IT EXTREMELY DIFFICULT TO ACCELERATE UPHILL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DETERMINED THAT THE FUEL PRESSURE REGULATOR HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE ISSUE. THE FAILURE MILEAGE WAS 140,000 AND THE CURRENT MILEAGE WAS 150,000.
Dec 03, 2012
I TRIED TO ACCELERATE ONTO INTERSTATE 85 N FROM EXIT 57 IN OPELIKA, AL DURING VERY BUSY TRAFFIC CONDITIONS AND COULD NOT GET ABOVE 60 MPH, WHICH NEARLY CAUSED AN ACCIDENT. THE FORD DEALER DIAGNOSED THE PROBLEM TO BE A FAILED HIGH PRESSURE FUEL PUMP WHICH WAS NOT COVERED BY THE FACTORY 100,000 MI. WARRANTY DUE TO WHAT THE DEALER AND A FORD MOTOR CO. REPRESENTATIVE FROM CUSTOMER RELATIONS SAID WAS CONTAMINATED FUEL DAMAGE. THE 6.4 L DIESEL FUEL SYSTEM IS EQUIPPED WITH A TWO FILTER AND FUEL/WATER SEPARATOR SYSTEM FOR THE PURPOSE OF FILTERING CONTAMINATES, INCLUDING WATER, WHICH OBVIOUSLY FAILED AND CONSEQUENTLY CAUSED DAMAGE TO THE HIGH PRESSURE FUEL PUMP. ALL SERVICES HAD BEEN PERFORMED AT THE FORD DEALERSHIP TO INCLUDE THE FUEL FILTERS. FORD SEEMS TO BE PLACING THE BLAME ON CONTAMINATED FUEL AS THE CAUSE FOR THE HIGH PRESSURE FUEL PUMP FAILURE WHEN THERE IS A HIGH PROBABILITY THAT IT IS A DEFECT IN THE FILTERING SYSTEM. *JS
Apr 30, 2012
NORMAL DRIVING, ACCELERATING TO SPEED LIMIT. THROTTLE STUCK WIDE OPEN AND WOULD NOT RETURN TO IDLE. DEALER REPLACE GAS PEDAL. HAVE OLD PART. *TR
Mar 04, 2010
ELECTRICAL SYSTEM,STRUCTURE
2 complaints
HAD JUST BACK THE VEHICLE IN CUT IT OFF, HALF AN HOUR LATER IT WAS IN FLAMES, BURNT EVERYTHING IN THE MOTOR AND FRONT OF TRUCK UP. *DT*JB *DT*JB *DT*JB *TR
Feb 17, 2019
THE MOON ROOF TRACK ON MY FORD F-350 (2008) FAILED AFTER ABOUT 5 YEARS. I HAD IT REPLACED AT JIM CLICK FORD IN TUCSON AT THE BEGINNING OF 2013 AT A COST OF $2400.00. AT THE BEGINNING OF 2015 IT FAILED AGAIN. NEITHER THE DEALER NOR FORD HAVE AN ANSWER FOR THE FAILURE(S) AND BOTH SAID I NEED TO DO THE REPAIR AGAIN AT MY EXPENSE. I FEEL THAT THE MOON ROOF APPARATUS SHOULD BE STURDY ENOUGH TO LAST THE LIFESPAN OF THE VEHICLE. MY CONTENTION IS THAT THIS ISSUE IS A DEFECT AND COULD BE A SAFETY ISSUE IS THE MOON ROOF IS BLOWN OFF OR CANNOT BE SEALED. FROM THE BEGINNING WITH THIS TRUCK WHEN I WOULD DRIVE IT FORWARD IN HIGH WINDS THE MOON ROOF WOULD LIFT AND CHATTER. THE FRAME IS PLASTIC AND NOT VERY STURDY. I'M SURE FORD USES THIS SAME PLASTIC FRAME ON MANY OF THEIR VEHICLES AND I THINK THAT RESEARCHING REPAIR RECORDS OF THOSE VEHICLES USING THIS FRAME MIGHT BE OF USE IN SEEING IF FAILURES ARE FREQUENT AND A POSSIBLE SAFETY ISSUE. *JS
Feb 25, 2015
STEERING,AIR BAGS
2 complaints
TL* THE CONTACT OWNS A 2008 FORD F-350 SD. WHILE THE VEHICLE WAS PARKED, THE STEERING WHEEL BECAME STUCK FOR TWO MINUTES AND THEN FAILED TO MOVE. THE AIR BAG WARNING LIGHT ILLUMINATED. THE CONTACT ATTEMPTED TO DRIVE THE VEHICLE AND THE STEERING WHEEL FAILED TO TURN. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.
Apr 19, 2016
DRIVING 15 TO 20 MPH AND STEERING PULLED TRUCK TO THE LEFT SHARPLY CAUSING ACCIDENT ALSO AIR BAG DID NOT WORK. *TR
Nov 24, 2008
AIR BAGS
2 complaints
TL* THE CONTACT OWNS A 2008 FORD F-350. WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE SLID ON ICE AND CRASHED INTO A PARKED TRAILER. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A BODY SHOP WHERE IT WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE FOR THIS CRASH WAS 80,000. IN ADDITION, WHILE DRIVING APPROXIMATELY 50 MPH, THE CONTACT STRUCK A DEER. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE VEHICLE WAS DRIVEN TO THE BODY SHOP WHERE IT WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THERE WERE NO INJURIES IN EITHER CRASH. THE APPROXIMATE FAILURE MILEAGE WAS 105,000.
Feb 19, 2015
TL* THE CONTACT OWNS A 2008 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, ANOTHER VEHICLE CRASHED INTO THE FRONT OF THE CONTACT'S VEHICLE AND THE AIR BAGS FAILED TO DEPLOY. ONCE THE VEHICLE WAS STOPPED, THE AIR BAGS THEN ERRONEOUSLY DEPLOYED. THERE WAS A POWDERY SUBSTANCE THAT WAS EMITTED FROM THE AIR BAGS, WHICH CAUSED THE CONTACT TO CHOKE AND BECOME ILL. THE CONTACT ALSO SUSTAINED INJURIES TO THE CHEST, HEART, NECK AND LOWER BACK. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS DESTROYED. THE FAILURE AND CURRENT MILEAGE WAS 24,000.
Jan 04, 2013
ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM
2 complaints
TL* THE CONTACT OWNS A 2008 FORD F-350 SD. THE CONTACT STATED THAT EXHAUST FUMES EMITTED INSIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHO INDICATED THAT THE EXHAUST FILTER WAS POORLY DESIGNED. THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. UPDATED 07/03/14 MA THE CONSUMER STATED THE FUMES IN THE VEHICLE CAN CAUSE ONE TO FEEL ILL. UPDATED 07/11/2014 *JS
Apr 29, 2014
WHILE DRIVING MY 2008 F-350 SUPERDUTY DIESEL POWERED TRUCK AT 45 MPH FOR APPROX 2 MILES, RECEIVED MESSAGE " "STOP SAFELY NOW" AND COMPLETE POWER DOWN OF ENGINE. THE TRUCK DECELERATED SO FAST THAT HAD WE NOT BEEN PASSING A PULL OFF LANE WE WOULD HAVE BEEN STUCK IN THE MIDDLE OF THE DRIVING LANE. THE WHOLE INCIDENT HAPPENED IN LESS THAN 10 SECONDS. AFTER GETTING OVER TO SIDE OF ROAD, ENGINE WOULD NOT CRANK OVER AND WAS NOT ALLOWED TO RESTART UNTIL AFTER THE ENGINE EITHER COOLED DOWN OR TIMED OUT (DIDN'T TRY FOR ABOUT AN HOUR LATER). BY TIME TOW TRUCK ARRIVED, WE HAD GOTTEN THE ENGINE TO START BUT DID NOT FEEL IT SAFE TO TRY AND MOVE THE VEHICLE AS WE HAD NO IDEA HOW FAR IT WOULD GO OR IF IT WOULD HAPPEN AGAIN. TRUCK WAS IN SHOP SERVICED FOR 60,000 AND HAD LATEST FORD RECALL FOR REPROGRAMMING COMPLETED LESS THAN 30 MILES PRIOR TO INCIDENT. WE WERE TOLD THERE WAS A TECH BULLETIN OUT ON THIS PROBLEM BUT IT WAS NOT COVERED UNDER THE ENGINE WARRANTY SO WE HAD TO PAY OUT OF POCKET. THE FIX IS ONLY HALF THE ISSUE; 10-15 SECOND IS NOT ENOUGH WARNING TO SAFELY PULL OFF THE ROAD. IF WE HAD BEEN PULLING OUR TRAVEL TRAILER, WE WOULD NOT EVEN BEEN ABLE TO GET AS FAR AS WE DID. THIS IS THE SECOND TIME A TECH BULLETIN ISSUE HAS HAPPENED TO US (PRIOR ISSUE WAS WITH A PRESSURE VALVE ON THE RADIATOR THAT CAUSED THE RADIATOR TO SPLIT) FORD SHOULD INFORM US OF POTENTIAL PROBLEMS SO WE CAN BE AWARE OF POSSIBLE ISSUES BEFORE THEY HAPPEN, NOT DRIVING DOWN THE ROAD.
Aug 19, 2011
SEAT BELTS
2 complaints
TL* THE CONTACT OWNS A 2008 FORD F-350. THE CONTACT STATED THAT THE REAR MIDDLE SEAT BELT WAS BROKEN. THE CONTACT TOOK THE VEHICLE TO THE DEALER BUT NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 55,000. UPDATED 01-29-14 *BF THE CONSUMER BELIEVED THE SEAT BELT WAS DEFECTIVE, LONG BEFORE THE HE PURCHASED THE VEHICLE. UPDATED 01/29/14
Jan 14, 2014
DRIVERS SIDE FRONT SEAT BELT REGULARLY UNFASTENED ITSELF WHILE VEHICLE IS BEING DRIVEN. *TR
Jan 19, 2010
ENGINE AND ENGINE COOLING,ENGINE
2 complaints
CUSTOMER SATISFACTION PROGRAM 08B06 WAS ISSUED BY FORD IN DECEMBER 2008. THIS NOTICE EXPIRED IN JUNE 30, 2009. I RECENTLY PURCHASED THE VEHICLE WITHIN THE LAST YEAR. THE SAME ISSUE HAS DEVELOPED THAT WAS IDENTIFIED IN THE ABOVE BULLETIN. THE PREVIOUS OWNER DID NOT GET THE SERVICE PERFORMED AND NOW FORD WILL NOT HONOR THE BULLETIN. THIS ISSUE SHOULD BE A RECALL ISSUE OR THE FORD CUSTOMER SATISFACTION BULLETIN SHOULD BE REOPENED OR RECREATED. THIS IS WITH REGARDS TO ENGINE COOLANT LEAK AND A KNOWN DEFICIENCY WITHIN THE COOLING SYSTEM. *TR
Aug 24, 2013
FAILURE OF FLEXIBLE JOINT IN THE EXHAUST UP-PIPE CREATES A FATAL SAFETY HAZARD FOR ALL OCCUPANTS OF THE VEHICLE. EXHAUST GASES LEAK FROM THE FAILED JOINT AND ENTER THE CAB OF THE TRUCK THROUGH THE HEATER VENTS. THIS CAN CAUSE THE OCCUPANTS TO BE OVERCOME BY EXHAUST GASES WHILE DRIVING, LEADING TO A FATALITY. THERE HAVE BEEN SEVERAL COMPLAINTS IDENTIFIED IN FORD BLOGS WITH REGARDS TO THIS AND NOTHING HAS BEEN DONE TO CORRECT THIS. *TR
Aug 24, 2013
FUEL SYSTEM, OTHER
2 complaints
TL*THE CONTACT OWNS A 2008 FORD F-350 SD. THE CONTACT STATED WHILE DRIVING 45 MPH THE FUEL SYSTEM EXPLODED. THE VEHICLE WAS TAKEN TO THE DEALER WHO CONFIRMED THAT THE FUEL SYSTEM WAS CONTAMINATED. THE VEHICLE WAS REPAIRED TWICE AND IT WAS REPAIRED THREE TIMES FOR THE SAME FAILURE. THE MANUFACTURER WAS CONTACTED. THE FAILURE MILEAGE WAS 26,000 AND THE CURRENT MILEAGE WAS 31,000. THE VIN WAS UNAVAILABLE.
May 25, 2011
PURCHASED A NEW 2008 FORD F-350 AND FOUND OUT FROM A FRIEND THAT THERE ARE TWO RECALLS ON MY TRUCK THAT I WAS NEVER NOTIFIED ABOUT
Sep 04, 2008
ENGINE AND ENGINE COOLING,EQUIPMENT
2 complaints
WHEN MY 08 F-250 DIESEL IS DRIVEN IN THE RAIN ON THE HIGHWAY AT A CONSTANT SPEED, THEN ACCELERATE TO PASS OR GO UP A GRADE IT HAS A HESITATION AND WHITE SMOKE OR STEAM. FORD REPLACED THE CAC WITH A NEW ONE THIS DID NOT FIX THE PROBLEM. I FILED A COMPLAINT WITH FORD THEY HOW EVER HAVE NO ANSWERS AS OF 15/FEB/2011 I FILED THE COMPLAINT BACK IN SEPTEMBER OF 2010. *TR
Feb 15, 2011
08 F350 WITH 70,000MILES ON IT. WE TOW A TRAILER DAILY WITH THIS VEHICLE. APPROXIMATELY 10 TIMES PER DAY IT STATES "CLEANING THE EXHAUST FILTER". ON SEPT. 29, 2010, IT SAID "CLEANING EXHAUST FILTER AND STOP SAFELY NOW" AND SHUT OFF IMMEDIATELY. WHILE I WAS IN THE MIDDLE OF ROAD. LUCKILY A FRIEND WAS DRIVING BY AND TOWED ME OUT OF THE LANE OF TRAFFIC. PRIOR TO THIS OUR VEHICLE HAD FOUR RADIATORS PUT INTO VEHICLE BECAUSE PLASTIC PARTS KEPT BREAKING. THE EXHAUST SENSOR WAS REPLACED PRIOR TO THIS INCIDENT. THE CODE FOR THIS WAS THE EXHAUST SENSOR. IF I WAS ON FOUR LANE HIGHWAY WHEN THE VEHICLE SHUT DOWN I'D BE DEAD. I DIDN'T HAVE ANY TIME TO PULL OFF ROAD. SOMETHING MUST BE DONE ABOUT THIS. FORD IS NOT STANDING BEHIND THIS. TRUCK IS STILL AT DEALER. I'VE BEEN WITHOUT VEHICLE SINCE SEPT. 29, 2010. THEY REFUSE TO PUT TRUCK BACK TOGETHER. THEY STATED THAT THIS WOULD BE WARRANTY BUT FORD WON'T WARRANTY AND I WON'T PAY WHAT THEY ARE ASKING FOR SOMETHING THAT IS A FREQUENT OCCURRENCE. *TR
Nov 01, 2010
SERVICE BRAKES, HYDRAULIC,VEHICLE SPEED CONTROL
2 complaints
BRAKE PEDAL LOCATION AND DEPRESSING VEHICLE'S BRAKE PEDAL AND GAS PEDAL AT THE SAME TIME. STREET DEPARTMENT WORKERS WEARING PROPER WORK BOOTS HAVE FOUND THAT THE PEDAL SPACING IS NOT ADEQUATE BETWEEN GAS PEDAL AND BRAKE PEDAL. THERE HAVE BEEN AT LEAST 10 TIMES WHERE THE EMPLOYEE HAS DEPRESSED THE BRAKE PEDAL AND THE VEHICLE WOULD NOT STOP. IT HAS BEEN DETERMINED THAT THE BRAKE PEDAL AND GAS PEDAL PLACEMENT ARE TO CLOSE TO EACH OTHER AND BOTH PEDALS CAN BE DEPRESSED AT THE SAME TIME GIVING THE OPERATOR THE FEELING OF NO BRAKE PEDAL AND THE VEHICLE NOT STOPPING. WE HAVE REPRODUCED THIS SITUATION AT LEAST 5 TIMES AND FEEL THAT IT IS IMPERATIVE THAT YOU BE NOTIFIED OF THIS DESIGN DEFECT. WE CONTACTED REUTEHR FORD, MIKE BOWEN A SERVICE ADVISOR AND THEY STATE THAT THEY ARE AWARE OF THIS SITUATION BUT FORD HAS NOT ADDRESSED IT AT THIS POINT. THIS IS A LAWSUIT WAITING TO HAPPEN. *TR
Nov 01, 2010
TL*THE CONTACT OWNS A 2008 FORD F-350 SUPERDUTY. THE CONTACT NOTICED AN INTERMITTENT ISSUE WITH THE BRAKES. WHEN THE BRAKE PEDAL WAS DEPRESSED, THE ENGINE WOULD REV AND THE VEHICLE WOULD ACCELERATE. HER SPOUSE SHOVED THE GEAR INTO PARK TO STOP THE VEHICLE. ON THE SECOND OCCASION, HE KEPT HIS FOOT ON THE BRAKE PEDAL UNTIL THE VEHICLE FINALLY STOPPED. THE DEALER BELIEVED THAT THE SPEED SENSORS CAUSED THE FAILURE. THE VEHICLE IS CURRENTLY BEING REPAIRED AND THE MANUFACTURER HAS NOT BEEN NOTIFIED. THE CURRENT MILEAGE WAS APPROXIMATELY 2,100 AND FAILURE MILEAGE WAS APPROXIMATELY 800. UPDATED 06/24/09. *LJ UPDATED 06/30/09.*JB
Jun 12, 2009
UNKNOWN OR OTHER
1 complaint
Items inside bed caught on fire due to exhaust cleaning system getting so hot to burn off pollution in DPF pipe. Dangerous truck to drive contacted ford. No one contacted me. Other ford diesels caught on fire due to this. I’m retired military and don’t have money to buy 50k trucks. Only 80k on truck.
Mar 01, 2025
SUSPENSION,WHEELS
1 complaint
DEATH WOBBLE-ERRATIC DRIVING WHEN THIS HAPPENED IT WAS IN MOTION ON A HIGHWAY.
Apr 07, 2021
STEERING,STRUCTURE,WHEELS
1 complaint
DRIVING THRU TOWN 25MPH OR LESS TURNING ONE CORNER FINE THEN ANOTHER CORNER THE OPPOSITE DIRECTION AND ONLY STEERING WHEEL TURNED.MY TRUCK WENT STRAIGHT INTO THE ROCK WALL DAMAGED HOOD FENDER,BUMPER,HEADLIGHT BEZEL AND LIGHTS DRIVER WHEEL, AND WHEN DIAGNOSED THE ORIGINAL PROBLEM IT WAS THE STEERING GEARBOX FAILURE
Jan 19, 2021
VISIBILITY/WIPER
1 complaint
DRIVING DOWN THE ROAD AT 65 MPH, ON OPEN HIGHWAY GOING STRAIGHT, AND ON CRUISE CONTROL, MY SUN ROOF EXPLODED. IF I HAD NOT HAD THE SUN SHADE PULLED CLOSED, WE WOULD HAVE BEEN SHOWERED IN GLASS! I HAD A TRUCK CAMPER ON THE TRUCK AT THE TIME, HOWEVER, I'VE DRIVEN TENS OF THOUSANDS OF MILES WITH THIS CAMPER, SO IT SHOULDN'T BE THAT - AND THE GLASS OUGHT TO BE STRONG ENOUGH FOR THIS USAGE ANYWAY. THIS SHOULD NOT HAVE HAPPENED, AND THE TYPE OF GLASS THAT IS USED SHOULD NOT ALLOW GLASS TO SHATTER INTO FLYING PIECES LIKE THAT! THIS IS COSTING ME A BUNDLE OF MONEY TO REPAIR, BUT MORE IMPORTANTLY, HAD THE SUN SHADE NOT BEEN CLOSED, I COULD HAVE HAD AN ACCIDENT WITH 6+ TONS OF TRUCK AND CAMPER.
Jun 25, 2019
SUSPENSION,STRUCTURE
1 complaint
TL* THE CONTACT OWNS A 2008 FORD F-350. WHILE DRIVING OVER A BUMP IN THE ROAD, THE VEHICLE SHOOK, BOUNCED, AND MADE A SQUEAKING NOISE. THE CONTACT CALLED SCHULTZ FORD LINCOLN (LOCATED AT 80 NU-304, NANUET, NY 10954, (877) 724-8589) AND WAS INFORMED TO CONTACT THE MANUFACTURER TO SEE IF THE VEHICLE WAS COVERED UNDER WARRANTY OR RECALLS. IN ADDITION, WHEN THE CONTACT CHECK UNDER THE VEHICLE, HE NOTICED THAT THE RUBBER BUSHING DISINTEGRATED FROM THE CAB AND CHASSIS. THE VEHICLE WAS NOT TAKEN TO A DEALER AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS OUT OF WARRANTY AND THERE WERE NO RECALLS ASSOCIATED WITH THE VIN. THE APPROXIMATE FAILURE MILEAGE WAS 48,000.
May 20, 2019
STEERING,UNKNOWN OR OTHER
1 complaint
THE TRUCK SHAKES A LOT WHEN GOING OVER BUMPS ON THE ROAD , AROUND 60 MPH .
Feb 10, 2018
POWER TRAIN,UNKNOWN OR OTHER,ENGINE
1 complaint
EXCESSIVE WHITE SMOKE OUT OF EXHAUST, ESPECIALLY WITH ACCELERATION. SMOKE HAS A FOUL ODOR ALSO. CAN HEAR A KNOCKING SOUND IN ENGINE ON DECELERATION (SIMILAR TO BAD WHEEL BEARING HUMS), ONLY DOES IT IF TURBO IS OVER 150-200 PSI, BUT WILL DO IT EVERY SINGLE TIME. 'DRIVE TO CLEAN EXHAUST' DISPLAYED ON DASH. COMPLETED RECOMMENDED DRIVE CYCLE (OVER 30MPH FOR AT LEAST 20 MINUTES, I DROVE FOR 45 MINS) AND MESSAGE STILL APPEARS. "WRENCH" SYMBOL DISPLAYED ON DASH. PER OWNER'S GUIDE THE RTT DISPLAYS WHEN ENGINE HAS DEFAULTED TO "LIMP-HOME" OPERATION OR WHEN TRANSMISSION PROBLEM HAS BEEN DETECTED.. THE LIGHT COMES ON EVERY TIME VEHICLE IS DRIVING NOW, AND STAYS ON ENTIRE TIME.
Mar 09, 2017
STRUCTURE
1 complaint
BED RAILS ARE ROTTING PREMATURELY CAUSING SAFETY CONCERN WHEN TRUCK IS TOWING OR THERE IS WEIGHT IN THE BED OF THE TRUCK I FEEL THAT THIS MAY CAUSE A SAFETY ISSUE FOR PASSENGERS IN THE TRUCK AS WELL AS OTHER MOTORIST ON THE ROADWAY. FIFTH WHEEL HITCH CONNECTION SHIFT BECAUSE OF ROTTED RAIL CAUSING JAM IN HITCH CREATING TRAVEL HAZARD
Sep 19, 2016
VEHICLE SPEED CONTROL,ENGINE
1 complaint
SUDDEN VEHICLE ACCELERATION DURING SLOWING/BRAKING. REGISTERED OVER 4000 RPM AT APPROXIMATELY 10 MPH WITH BRAKES FULLY DEPRESSED AND WAS EXTREMELY DIFFICULT TO STOP WHICH ALMOST LED TO A REAR END COLLISION. AFTER COMING TO A COMPLETE STOP, VEHICLE WAS PUT INTO PARK AND ENGINE SLOWLY DECREASED FROM RACING AND WENT TO NORMAL RPM OPERATING RANGE AT IDLE WITHIN SECONDS. *TR
Mar 30, 2015
STEERING,WHEELS,SERVICE BRAKES
1 complaint
I WAS DRIVING ON INTERSTATE 75 WHEN THE TRUCK AND STEERING WHEEL STARTED VIBRATING VIOLENTLY, AS I APPLIED THE BRAKES TO SLOW THE VEHICLE IT PULLED SHARP TO THE LEFT TAKING THE VEHICLE ONTO THE MEDIAN. ONCE THE VEHICLE STOPPED, FACING IN THE OPPOSITE DIRECTION I GOT OUT AND CHECKED THE LEFT FRONT WHEEL, IT WAS TOO HOT TO TOUCH. I LET IT COOL AND THEN PROCEEDED TO THE NEAREST EXIT. I HAD THE LEFT FRONT WHEEL INSPECTED, BUT NO PROBLEM WAS DISCOVERED. I CONTINUED ON MY TRIP FROM TENNESSEE TO FLORIDA. ON THE RETURN TRIP THE PROBLEM HAPPENED THREE TIMES, EACH TIME I STOPPED AND LET THE WHEEL COOL BEFORE CONTINUING. I RESEARCHED THIS PROBLEM ON THE INTERNET AND FOUND THAT SEVERAL OTHER INDIVIDUALS HAVE EXPERIENCED THE SAME PROBLEM. I BELIEVE THE NTSB SHOULD REQUIRE FORD MOTOR COMPANY TO RECALL THESE VEHICLES AND CORRECT THE PROBLEM BEFORE SOMEONE IS INJURED OR KILLED. THERE IS SUFFICIENT DOCUMENTATION ON THE INTERNET TO JUSTIFY THE NTSB TAKING ACTION. *TR
Oct 01, 2014
STEERING,ENGINE
1 complaint
ON SEPTEMBER 30, 2014, MY WIFE WAS ON HER WAY TO COLUMBUS, OHIO IN HER 2008 FORD F350 SUPER DUTY TURBO DIESEL TRUCK (VIN# [XXX]) WITH 44,000 MILES. SHE'S PULLING HER 2014 26? LAKOTA TWO HORSE TRAILER WITH LIVING QUARTERS WITH HER SHOW HORSE IN THE BACK. THE UNEXPECTED HAPPEN WHILE SHE WAS ON MD-51N NEAR CUMBERLAND, MARYLAND HEADING ACROSS A BRIDGE WITH HEAVY TRAFFIC AT 1230PM. THE CHECK ENGINE LIGHT CAME ON WITH THE FOLLOWING MESSAGE ?PULL OVER SAFELY?. TWENTY SECONDS (20 SECONDS) LATER, THE TRUCK COMPLETELY SHUT DOWN. WIFE WAS TRAVELING AT 70 MILES AN HOUR WHEN THE TRUCK SHUT DOWN, WHICH TURNED THE POWER STEERING OFF. THIS IS WHAT I CALL UNSAFE FOR ANYONE, ESPECIALLY WHEN PULLING A 26? HORSE TRAILER WITH AN EXTRA 1000LBS IN THE BACK WITH A HORSE. SHE WAS NOT ABLE TO GET COMPLETELY OFF THE ROAD WHICH ALMOST CAUSED A MAJOR ACCIDENT DUE TO THE VEHICLE SHUTTING DOWN ON HER. AFTER SITTING ON THE SIDE OF THE ROAD WAITING FOR AAA TO COME TOW THE VEHICLE FOR OVER 1 HOURS, THE VEHICLE STARTED BACK UP AND SHE DROVE IT TO FORD CUMBERLAND, 10335 MT SAVAGE ROAD NW, CUMBERLAND, MD WITH THE CHECK ENGINE LIGHT STILL ON WITH A POLICE ESCORT SINCE THE SHERIFF OF CUMBERLAND SAT WITH MY WIFE ON MD-51N WAITING ON AAA. THIS IS AFTER SHE WAS ALMOST HIT BY A FEDEX EIGHTEEN WHEELER DUE TO NOT BEING ABLE TO GET TO A SAFE LOCATION FOR A TRUCK AND HORSE TRAILER DUE TO THE VEHICLE SHUTTING DOWN ON HER. THE DEALERSHIP FOUND THE PROBLEM: EXHAUST SENSOR. THEY WERE ABLE TO REPAIR IT AND SHE WAS ABLE TO CONTINUE ON WITH HER TRIP. HOW CAN THIS SENSOR GO OUT ON A TRUCK WITH ONLY 44,000 MILES ON IT? HOW CAN THEY DESIGN A TRUCK TO SHUT DOWN AUTOMATICALLY WITHOUT ANY WARNING? THE DEALERSHIP TOLD MY WIFE THEY HAVE SEEN THESE SENSORS GO OUT AT 20,000 MILES BEFORE. NEEDS TO BE ADDRESS AND RECALL ISSUED BEFORE SOMEONE DIES ON THE HIGHWAY DUE TO THIS PROBLEM. HOLD FORD ACCOUNTABLE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Sep 30, 2014
STRUCTURE,TIRES,WHEELS
1 complaint
I WAS DRIVING A F-F350 SD CREW CAB PICKUP TRUCK WITH A TRUCK SHELL TOP APPROXIMATELY 65 MPH WHEN THE LEFT REAR TIRE TREAD BEGAN TO SEPARATE FROM THE TIRE CORD, RESULTING IN THE TREAD THRASHING (APPROXIMATELY 6 REVOLUTIONS) THE INTERIOR AND EXTERIOR OF THE LEFT REAR QUARTER PANEL CAUSING EXTREME BODY DAMAGE TO THE WHEEL WELL, BUMPER, UPPER TRUCK SHELL SLIDING WINDOW. THIS WAS A VERY VIOLENT EXPLOSION WHEN THE TREAD FINALLY SEPARATED AND FLEW OFF THE TIRE CORD. I THEN STOPPED THE VEHICLE, ASSESSED THE PROBLEM, RETRIEVED THE TIRE TREAD WHICH REMAINED INTACT, ALSO IN ONE PIECE...! AMAZINGLY, THE TIRE CORD REMAINED INTACT, STILL PRESSURIZED AND HOLDING AIR... AND I WAS ABLE TO LIMP HOME AT APPROXIMATELY 30 MPH. WENT TO THE FORD DEALERSHIP,WHO WERE NOT INITIALLY HELPFUL POINTING THE FINGER TO B.F. GOODRICH, WHO I DID CALLED AND I RECEIVED A RETURN PHONE CALL THE NEXT DAY. I THEN WENT TO THE DEALERSHIP AGAIN, WHO REMOVED THE TIRE, AND PRESERVED THE TREAD AND TIRE, AND I WAS INSTRUCTED BY THE B.F. GOODRICH REPRESENTATIVE TO SHIP THE TIRE FOR INSPECTION TO THEIR OFFICES. THE INITIAL INSPECTION AT THE FORD DEALERSHIP WAS FOUND TO BE INCONCLUSIVE... AS TO WHETHER OR NOT THE SEPARATION WAS CAUSED BY A ROAD HAZARD, WHICH IT WAS NOT, AND THEN I WAS TOLD I WOULD HAVE TO SHIP THE TIRE TO THEM FOR FURTHER INVESTIGATION, AND WHETHER OR NOT THEY WOULD PROVIDE REIMBURSEMENT FOR THE $3-$4K IN BODY DAMAGE TO MY TRUCK. PREPARING THE TIRE FOR SHIPPING TO B.F.GOODRICH AND WAITING ON THE STATUS OF THE REMAINDER OF MY BODY DAMAGE CLAIM. *TR
Jul 03, 2014
STEERING,STRUCTURE
1 complaint
ON THE EVENING OF 6/13/2014, I WAS DRIVING MY 2008 FORD F-350 THROUGH THE DRIVE THROUGH LINE OF WHITE CASTLE IN COMMACK, NEW YORK, 11725. AS I WENT TO MAKE A RIGHT TURN TO FOLLOW THE DRIVE THROUGH LANE, A HEARD A METAL BREAKING SOUND FOLLOWED BY COMPLETE LOSS OF STEERING. WITHIN LESS THAN 1 SECOND FROM THIS HAPPENING, MY VEHICLE COLLIDED WITH A CINDER BLOCK WALL CAUSING SIGNIFICANT FRONT END DAMAGE TO THE BUMPER, FENDER AND HEADLIGHT. THERE WERE NO INJURIES TO MYSELF OR ANY PASSENGERS AS WELL AS THE WALL HAD MINIMAL DAMAGE. I HAD A POLICE REPORT FILED WITH THE SUFFOLK COUNTY POLICE DEPARTMENT. THE REPORT CORROBORATES MY STATEMENT OF COMPLETE STEERING LOSS AS THE DIRECT RESULT OF THE ACCIDENT. THE VEHICLE WAS TOWED TO MY MECHANIC, NORTH SHORE FIRESTONE IN COMMACK. UPON INVESTIGATION THEY DETERMINED THE GEARS INSIDE OF THE STEERING BOX COMPLETELY FAILED. THEY COULD BE OF FURTHER ASSISTANCE DETAILING WHAT THE INTERNALS OF THE STEERING BOX LOOKED LIKE IF NEEDED. THEY ALSO INFORMED ME THERE IS A 2 MONTH BACK LOG ON THE REPLACEMENT FOR THIS PART. BEING THAT THERE IS A REPLACEMENT BACKLOG, FORD MUST KNOW THERE IS A DESIGN FLAW. THIS PART NEEDS TO BE REDESIGNED TO STAND UP TO THE DIFFICULT TASK OF GETTING WHITE CASTLE! THIS FAILURE NOT ONLY CAUSED DAMAGE TO MY TRUCK COSTING OVER $5,000, BUT THIS WILL CAUSE MY INSURANCE TO GO UP AS WELL. IF THIS CAUSES ME TO BE DROPPED FROM MY INSURANCE, I WILL HAVE MAJOR PROBLEMS BEING THAT ALL OF MY JOBS REQUIRE ME TO HAVE TRANSPORTATION. PLEASE HAVE FORD FIX THIS PROBLEM SO NO ONE ELSE IS INVOLVED IN AN ACCIDENT. I WAS LUCKY I WAS GOING AT A LOW SPEED, BUT THE NEXT PERSON MAY NOT BE AS LUCKY AS I WAS. *TR
Jun 27, 2014
STEERING,TIRES
1 complaint
TL* THE CONTACT OWNS A 2008 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE POWER STEERING FAILED CAUSING THE VEHICLE TO VEER ERRATICALLY. THE VEHICLE WAS TAKEN TO THE DEALER MULTIPLE TIMES. THE TECHNICIAN WAS UNABLE TO DETERMINE THE FAILURE IN ANY OF THE OCCASIONS. THE TECHNICIAN ADVISED THAT THE LOW TIRE PRESSURE SENSOR, TIRES AND THE STEERING STABILIZER FAILED, ALL WHICH MAY HAVE BEEN SEEMINGLY RELATED TO THE FAILURE. THE VEHICLE WAS REPAIRED BUT THE FAILURE WAS NOT CORRECTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 95,000 AND THE CURRENT MILEAGE WAS 102,000.
May 30, 2014
STEERING,POWER TRAIN
1 complaint
TL* THE CONTACT OWNS A 2008 FORD F-350 SD. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE POWER STEERING ASSIST FAILED AS THE STEERING WHEEL SEIZED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING, WHO STATED THAT THE GEARBOX HAD FAILED. THE VEHICLE HAD BEEN REPAIRED ONCE IN THE PAST FOR THE SAME FAILURE. THE FAILURE WAS REPORTED TO THE MANUFACTURER. THE FAILURE MILEAGE WAS 52,000. THE CURRENT MILEAGE WAS 70,576.
Jul 03, 2013
POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE
1 complaint
ON MULTIPLE OCCASIONS, WHEN VEHICLE IS STOPPED, WITH BRAKE DEPRESSED, THE ENGINE REVS UP AND VEHICLE WANTS TO ACCELERATE FORWARD AT A HIGH RATE OF SPEED. THE ONLY WAY TO STOP THE ACCELERATION IS TO GET THE VEHICLE TRANSITIONED IN TO PARK AND CUT THE ENGINE. THE VEHICLE HAS BEEN TO THREE DEALERS, WHOM ARE UNABLE TO DIAGNOSE AND CORRECT THE PROBLEM. FORD HAS NOT BEEN RESPONSIVE. VEHICLE IS UNSAFE TO DRIVE. *TR
Jan 18, 2013
SUSPENSION,ENGINE AND ENGINE COOLING
1 complaint
UPON INSPECTION OF THIS VEHICLE,OUR MECHANIC FOUND THE AUTOMATIC DIPSTICK TUBE RUSTED IN HALF ON THE RIGHT SIDE OF THE ENGINE. AT THE BRACKET THAT BOLTS TO THE EXHAUST MANIFOLD. WE BELIEVE THIS TO BE A POTENTIAL FIRE /SAFETY HAZARD IF SOME ONE WAS TO FILL OR CHECK THE TRANSMISSION WHILE THE ENGINE IS HOT. WE ALSO FOUND THE RIGHT SIDE SHOCK TOWER SEVERELY DEGRADED BECAUSE OF RUST. THE TOP OF THE TOWER HAS LARGE PIECES OF RUST SCALE ON TOP OF THE TOWER THAT WE FEEL COULD POSSIBLY ALLOW THE COIL SPRING PRESSURE TO FRACTURE THE STEEL AND CAUSE A LOSS OF STEERING. I HAVE NOT SEEN THIS MUCH CORROSION ON A TRUCK THIS NEW. WE HAVE TAKEN PICTURES AND CAN BE E-MAILED IF NEEDED. THIS VEHICLE HAS BEEN REMOVED FROM SERVICE UNTIL IT CAN BE REPAIRED. THIS IS A CITY OF ALLENTOWN ,PA FLEET VEHICLE. *TR
Oct 13, 2012
STEERING,SUSPENSION,WHEELS
1 complaint
START OF MULTIPLE OCCURRENCES OF DEATH WOBBLE WITH THIS TRUCK AND NUMEROUS TRIPS TO THE FORD DEALERSHIPS WITH NO FIX. TIRES REPLACED APPROXIMATELY 28,000 MILES AT MY EXPENSE: ( WAS TOLD THIS WOULD MOST LIKELY FIX THE WOBBLE). I WAS ADVISED THE FRONT END ALIGNMENT OUT (CASTER SETTING) AND COULD NOT BE FIXED BY FORD BECAUSE THE CASTER ADJUSTERS NECESSARY TO REPAIR - NOT AVAILABLE AT THE TIME. BUT FORD ADVISED ME THE ALIGNMENT WITHOUT THE CASTER ADJUSTERS WAS STILL WITHIN FORD SPECS AND WOULD BE FINE. LAST VISIT TO THE DEALERSHIP FOR THE DEATH WOBBLE AROUND 09-19-2012, VEHICLE @ 34,090. ADVISED THE MECHANIC ATTEMPTED TO ALIGN VEHICLE WITH CASTER ADJUSTER SLEEVES; WAS UNABLE TO FIX, WRONG SLEEVES. WOULD HAVE BEEN CHARGED FOR THE REPAIR APPROX. 400.00. I WAS TOLD THAT IF I HAD THE FRONT ALIGNED CORRECTLY IT WOULD TAKE CARE OF DEATH WOBBLE. 95% SURE IT WOULD FIX. I FINALLY WENT TO LOCAL MECHANIC SHOPS. FIXED WOBBLE WITH 2 STEERING STABILIZERS @ 324.74 CHARGE. ALIGNMENT WITH CASTER SLEEVES @ 414.22 CHARGE. I AM PLANNING TO ASK FORD FOR REIMBURSEMENT BUT I DOUBT THEY WILL COMPLY. *TR
Sep 26, 2012
ENGINE AND ENGINE COOLING,FUEL SYSTEM, DIESEL,ELECTRICAL SYSTEM
1 complaint
WHILE DRIVING MY 2008 F350 SUPERDUTY DIESEL POWERED TRUCK AT 45MPH FOR APPROX 4 MILES, RECEIVED MESSAGE "EXHAUST DRIVE COMPLETE" IMMEDIATELY FOLLOWED BY "STOP SAFELY NOW" AND COMPLETE POWERDOWN OF ENGINE. THE TRUCK DECELERATED SO FAST THAT DESPITE MY FLOORING THE THROTTLE, THE CAR BEHIND ME ALMOST COLLIDED. THE TRUCK LOST SO MUCH POWER THAT I COULD NOT SAFELY PULL OFF ROAD AND WAS IN A RURAL AREA BETWEEN TWO BLIND CURVES. THE WHOLE INCIDENT HAPPENED IN LESS THAN 30 SECONDS AND LEFT TRUCK COMPLETELY VULNERABLE TO WHATEVER TRAFFIC CONDITIONS WERE AT THE TIME OF INCIDENT. AFTER GETTING OVER TO SIDE OF ROAD, TRUCK STALLED ON SLIGHT RISE AND DID NOT HAVE THE POWER TO MOVE, HOWEVER WHEN I SHUT TRUCK DOWN, MY 5FT8IN 200LB BODY WAS ABLE TO PUSH THE 8000 LB VEHICLE OVER THE HUMP. ENGINE WOULD NOT CRANK OVER AFTER INCIDENT AND WAS NOT ALLOWED TO RESTART UNTIL AFTER THE UNIT EITHER COOLED DOWN OR TIMED OUT (DIDN'T TRY FOR 30-45 MIN LATER). BY TIME TOW TRUCK ARRIVED, UNIT WOULD RUN BUT LESS THAN FULL POWER AND CHECK ENGINE LIGHT WAS ON. TRUCK WAS IN SHOP SERVICED FOR FAULTY EGR VALVE AND HAD LATEST FORD RECALL FOR REPROGRAMMING COMPLETED LESS THAN 100 MILES PRIOR TO INCIDENT. *TR
Jun 23, 2011
VISIBILITY
1 complaint
I BOUGHT MY 2008 F350 TRUCK FROM CARBON FORD ON APRIL 25, 2010. AT THE TIME, THE TRUCK HAD AFTER MARKET WINDOW TINT ON IT. RATHER THAN REMOVE THE TINT, THEY DIRECTED ME TO ANOTHER INSPECTION STATION SO THAT THE TRUCK WOULD PASS BY ROLLING DOWN THE WINDOWS (IT FAILED ONCE). 1 YEAR LATER, I HAVE THE SAME ISSUE AGAIN. THIS TIME HOWEVER, I HAVE LEARNED THAT THE TRUCK THEY SOLD ME WAS ACTUALLY INVOLVED IN A ROLLOVER (NOT PROPERLY DISCLOSED). WHEN I BOUGHT THE VEHICLE, I KNEW THAT IT HAD BEEN IN AN ACCIDENT. I TOLD THEM I NEEDED TO KNOW WHAT HAPPENED BEFORE PURCHASING IT. THEY SAID IT JUST HIT A SNOW BANK AND NO BIG DEAL. THEY ACTUALLY CALLED SOMEONE TO CONFIRM THIS. THEY ARE NOT WILLING TO FIX THE VEHICLE AND ARE OFFERING ME ONLY A VERY SMALL DOLLAR AMOUNT. MEANWHILE, THE WINDOWS ARE STILL TINTED AND IT WILL NOT PASS INSPECTION. [XXX] (I BELIEVE A MANAGER THERE), INSTRUCTED ME TO GO TO A GARAGE THAT CARBONE WORKED CLOSELY WITH IN THE PAST. HE TOLD ME TO TELL THEM THAT CARBONE SENT ME AND THAT THEY WOULD PASS THE VEHICLE EVEN WITH THE VERY DARK TINTED WINDOWS THAT CAME ON THE TRUCK. THEY ARE SELLING VEHICLES THAT DO NOT PASS INSPECTION, AND THEN FINDING WAYS AROUND IT SO THAT THEY DON'T HAVE TO FIX THEM. I WAS TOLD THAT IF I TRY TO GET THE INSPECTION, I WILL GET A RED REJECTION STICKER AND WILL NOT BE ABLE TO DRIVE THE TRUCK ANYMORE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Jun 06, 2011
STEERING,VEHICLE SPEED CONTROL
1 complaint
LETTER FROM SENATOR BROWN ON BEHALF OF CONSTITUENT RE HIS FORD TRUCK GAS PEDAL ACCELERATING, CAUSING HIM TO CRASH (DOT/I#2010-1130) *TGW THE CONSUMER STATED WHILE DRIVING ON A RURAL ROAD, THE STEERING LOCKED UP AND THE GAS PEDAL BECAME STUCK WHICH CAUSED THE VEHICLE TO ACCELERATE OUT OF CONTROL AND CRASH INTO AN EMBANKMENT. THE CONSUMER WAS KNOCKED UNCONSCIOUS AND WHEN HE CAME TO THE ACCELERATOR PEDAL WAS PRESSED TO THE FLOOR. HE WAS ABLE TO RELEASE THE ACCELERATOR PEDAL SO HE PROCEEDED TO MOVE THE VEHICLE TO THE SIDE OF THE ROAD. AS HE DID THAT, THE STEERING LOCKED UP A SECOND TIME, SO HE TURNED OFF THE ENGINE AND WAITED FOR THE POLICE TO ARRIVE. THE CONSUMER SUFFERED A MILD CONCUSSION. THE CONSUMER STATED FORD NOR HIS INSURANCE COMPANY WERE WILLING TO PAY FOR THE REPAIRS FOR THE DEFECTIVE STEERING BOX. *JB
Jun 04, 2010
ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL
1 complaint
I PURCHASED A 2008 FORD 350 SUPER DUTY KING RANCH WITH A 6.4L DIESEL AND STARTED HAVING THROTTLE PROBLEMS @ ABOUT 5,000 MILES. I HAD REPEATED PROBLEMS WITH THROTTLE RESPONSE. I WAS DRIVING DOWN THE HWY @ 70MPH AND THE TRUCK JUST WENT INTO IDLE MODE AND WOULD NOT RESPOND TO THE THROTTLE PEDAL. I WAS VERY LUCKY TO BE ABLE TO WEAVE THRU TRAFFIC AND PULL OVER TO THE SIDE OF THE ROAD. I SHUT THE TRUCK OFF AND SAT THERE FOR A FEW MINUTES THEN RESTARTED THE TRUCK AND DROVE OFF. ON NUMEROUS OCCASIONS I WOULD START THE TRUCK AND IT WOULD DRIVE A SHORT WAYS AND THEN KICK INTO IDLE MODE AND THE ENGINE WOULD NOT RESPOND TO THE PEDAL. I HAD THE TRUCK TOWED INTO THE FORD DEALER AND THEY SAID THEY COULD NOT DUPLICATE THE PROBLEM. THEY REPLACED THE THROTTLE PEDAL SENSOR AND GAVE IT BACK TO ME. I FILED A COMPLAINT WITH CUSTOMER SERVICE ON 6/18/2009 CASE # [XXX] AS THE PROBLEM CONTINUED TO HAPPEN. I HAD THE TRUCK TOWED IN AGAIN AND THE FORD DEALER REPLACED THE MAP SENSOR. THE PROBLEM CONTINUED TO HAPPEN AND I HAD THE TRUCK TOWED INTO THE FORD DEALER AGAIN AND LEFT IT WITH THEM. THEY CALLED ME BACK AND SAID THE TRUCK WAS READY TO PKUP. I WAS UNDER THE IMPRESSION THAT THEY HAD CHANGED A PART OR CORRECTED THE PROBLEM. I INFORMED THEM THAT I WAS GOING ON A HUNTING TRIP TO UT IN LATE DECEMBER AND WANTED TO ENSURE MY TRUCK WAS IN FACT REPAIRED. I DROVE TO ELKO NV AND SPENT THE NIGHT. THE NEXT DAY (SUNDAY) I STARTED THE TRUCK AND IT KICKED INTO IDLE MODE AND WOULD NOT RESPOND TO THE THROTTLE. I HAD IT TOWED TO THE FORD DEALER AGAIN. THE NEXT DAY THEY REFLASED THE COMPUTER IN THE TRUCK AND SAID THEY HOPED IT WOULD GET ME HOME. WHEN I RETURNED HOME I TOOK THE TRUCK INTO THE LOCAL FORD DEALER AGAIN. THEY SAID THEY COULD NOT DUPLICATE THE PROBLEM. THEY DID CHANGE OUT THE PCM AND GAVE ME BACK THE TRUCK BUT WOULD NOT CONFIRM THEY FIXED THE PROBLEM. I WAS IN CONTACT WITH FORD CUST SERVICE AND REQUESTED A BUY BACK. THEY REFUSED. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Apr 13, 2010
ENGINE AND ENGINE COOLING,FUEL SYSTEM, DIESEL,POWER TRAIN,EXTERIOR LIGHTING
1 complaint
TL* THE CONTACT OWNS A 2008 FORD F350 SUPER DUTY TRUCK PURCHASED NEW. HE STATED AFTER HAVING A REGULAR OIL CHANGE, HE NOTICED A LARGE OIL SPILLAGE COMING FROM UNDER THE VEHICLE. THE DEALER ADVISED REPLACING THE HIGH PRESSURE FUEL PUMP. THE REPAIR CAUSED THE OIL TO LEAK WORSE. WITHIN JUST UNDER A YEAR OF THE INITIAL FAILURE, THE DEALER REPLACED THE HIGH PRESSURE FUEL PUMP A SECOND TIME. SEVERAL MONTHS LATER, THE CONTACT BEGAN TO NOTICE THE OIL LEAK AGAIN. THE HIGH PRESSURE FUEL PUMP WAS REPLACED A THIRD TIME. HE ALSO STATED THE BULBS IN THE EXTERIOR LIGHTING ELEMENTS, INCLUDING HEADLIGHTS, TAIL LIGHTS AND TURN SIGNALS CONTINUED TO BLOW. THE DEALER COULD NOT IDENTIFY THE REASON WHY THEY CONTINUED TO FAIL. WHILE AT A STOP, WHILE ATTEMPTING TO ACCELERATE, THE VEHICLE WOULD NOT SHIFT INTO GEARS PROPERLY. THE VEHICLE WOULD STAY IN HIGH GEAR AND WOULD NOT DOWN SHIFT PROPERLY. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. NO FURTHER REPAIRS WERE MADE TO DATE. THERE WERE NO RECALLS ON HIS VEHICLE. THE FAILURE AND CURRENT MILEAGES WERE UNDER 28,000.
Feb 03, 2010
SERVICE BRAKES, HYDRAULIC,STRUCTURE
1 complaint
ON FEBRUARY 21, 2009, I PURCHASED A 2008 FORD F-350 FROM EL CAJON FORD. SINCE THAT TIME, I HAVE EXPERIENCED AT LEAST SIX INCIDENTS OF ACCIDENTALLY PRESSING THE ACCELERATOR PEDAL WHILE MY FOOT IS OPERATING THE BRAKE PEDAL. THE LATEST INCIDENT WAS ON 9/21/2009, AND OCCURRED WHILE BACKING THE TRUCK INTO A PARKING SPACE. I CAME EXTREMELY CLOSE TO HITTING A CONCRETE BLOCK WALL. THESE INCIDENTS ARE QUITE FRIGHTENING, AND I AM CONCERNED THAT IT IS ONLY A MATTER OF TIME BEFORE SOMEONE IS SERIOUSLY INJURED. THIS LATEST INCIDENT HAS LEFT ME SO STARTLED, THAT I AM AFRAID TO CONTINUE TO DRIVE THE VEHICLE. I HAVE OWNED TWO OTHER FORD F-350 TRUCKS, A 1990 (9 YEARS), AND A 1999 (10 YEARS). IN THE 19 YEARS AND 350,000 MILES I DROVE THOSE TWO TRUCKS, I NEVER, EVER, HAD THIS OCCUR WITH EITHER VEHICLE. THERE IS OBVIOUSLY SOMETHING DIFFERENT ABOUT THE 2008. I BELIEVE THAT THE SEPARATION OF THE BRAKE AND GAS PEDALS IS INSUFFICIENT. I HAVE RESEARCHED THIS ISSUE ON TWO FORD TRUCK INTERNET FORUMS, AND HAVE DISCOVERED THAT I AM NOT THE ONLY PERSON EXPERIENCING THIS ISSUE. *TR
Sep 24, 2009
ENGINE AND ENGINE COOLING,FUEL SYSTEM, DIESEL,POWER TRAIN,UNKNOWN OR OTHER
1 complaint
2MONTHS INTO MY "NEW" VEHICLE THE RADIATOR CRACKED AND OVER HEATED ; THE BACK GLASS LEAKS WITH WATER EVERY TIME IT RAINS , MOTOR REVES UP OUT OF CONTROL , NOW MOTOR HAS BLOWN OIL INTO RADIATOR AND ALL OVER DRIVEWAY DEEMING VEHICLE UNDRIVEABLE. *TR
Feb 06, 2009
STEERING,ENGINE AND ENGINE COOLING,AIR BAGS,STRUCTURE
1 complaint
JUNE 25, 2007, WE WERE IN MONTANA AND HAD JUST COME DOWN FROM APPROX. 14,000 FT. PASS, CLOSED SUN ROOF ON OUR 2008 FORD F350 CREWCAB DIESEL, ALL 4 OCCUPANTS (3 ADULTS & 1 CHILD) FELL ASLEEP @ 2:00 PM IN THE AFTERNOON. PASSENGER WOKE AS WE WERE GOING OFF THE PAVEMENT, TRIED TO PUT TRUCK BACK ON PAVEMENT BUT FRONT OF TRUCK WOULD NOT GET UNDER CONTROL, HIT MAIL BOXES AND VEERED TO LEFT (STILL UNABLE TO CONTROL) NOT SPEEDING, HIT HEAD ON INTO TREES, ROLLED TO ROOF. AIR BAGS DID NOT DEPLOY ON EITHER SIDE, DRIVER SIDE (FRONT AND BACK) ROOF CRUSHED TO TOP AND INTO FRONT DRIVERS SEAT AND ALMOST TO FRAME OF WINDOW IN THE BACK SEAT. WHY OR WHAT CAUSED US ALL TO FALL ASLEEP AFTER CLOSING SUN ROOF, WHY WERE WE NOT ABLE TO CONTROL FRONT OF TRUCK (TOO HEAVY?), WHY DID AIR BAGS NOT DEPLOY AND WHY DID ROOF CRUSH SO FAR ON A ROLL TO ROOF, WE DID NOT ROLL COMPLETELY OVER. TRUCK WAS TOTALED. NO DEATHS OCCURRED, DRIVER RESULTED IN A BROKEN NECK AND PASSENGERS WITH RIB AND NECK INJURIES. *TR
Nov 12, 2008
SEATS
1 complaint
I PURCHASED MY 2008, FORD F350 IN AUGUST 2007 AND HAVE NOT RECEIVED ANY OF THE 5 RECALLS FROM FORD. I'M VERY CONCERNED ABOUT THE SAFETY OF MY FAMILY THAT TRAVEL WITH ME. I WANT TO FILE A COMPLAINT AGAINST FORD FOR NOT NOTIFYING ME ABOUT THE RECALLS, AND ALSO WANT TO KNOW WHY THEY HAVE NOT CONTACTED ME ABOUT ANY OF THE RECALLS. I WOULD APPRECIATE A RESPONSE FROM YOU ON WHAT WILL BE DONE ABOUT MY COMPLAINT. THANKS, *TR UPDATED 07/21/09
May 29, 2008
FUEL SYSTEM, OTHER,POWER TRAIN,VEHICLE SPEED CONTROL
1 complaint
TL*THE CONTACT OWNS A 2008 FORD F-350 SD. WHILE DRIVING 60 MPH, THE VEHICLE DECELERATED TO APPROXIMATELY 30 MPH. THE CONTACT STATED THAT WHEN THE CRUISE CONTROL IS ENGAGED, THE VEHICLE DOWNSHIFTS AND BECOMES STUCK IN FOUR WHEEL DRIVE. THE DEALER STATED THAT THE VEHICLE COULD NOT BE REPAIRED UNTIL THE FOURTH QUARTER OF 2007 AND THEY HAVE TO WAIT ON THE PCM CALIBRATION. CURRENTLY, THE DEALER IS UNSURE OF WHAT CAUSED THE FAILURE. THE CURRENT MILEAGE WAS 4,683 AND FAILURE MILEAGE WAS 4,400. THE DEALER STATED RELEASED AIR POCKET IN FUEL LINE REGENERATION PROCESS, HARD TO GET OUT OF FOUR WHEEL DRIVE, AND WAITING ON NEW PCM CALIBRATION. UPDATED 09/10/07 *TR
Aug 21, 2007
STEERING,SUSPENSION,ENGINE AND ENGINE COOLING
1 complaint
TWO ISSUES REALLY: A SLOPPILY INSTALLED VALVE COVER GASKET ON THE RIGHT VALVE COVER CAUSING FLUID LEAKAGE. THE SECOND IS A CONSTANT DRIFT TO THE LEFT. 2008 F-350 LARIAT 4X4 CREWCAB LONG BED POWERSTROKE DIESEL. *JB
Aug 01, 2007
Frequently Asked Questions
How many problems does the 2008 FORD F-350 have?
The 2008 FORD F-350 currently has 231 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.
What are the most common problems with 2008 FORD F-350?
The most common problems reported for the 2008 FORD F-350 are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.
Where does this 2008 FORD F-350 problem data come from?
All problem and complaint data for the 2008 FORD F-350 comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.
Other Years - FORD F-350
2025 Problems
2024 Problems
2023 Problems
2022 Problems
2021 Problems
2020 Problems
2019 Problems
2018 Problems
2017 Problems
2016 Problems
2015 Problems
2014 Problems
2013 Problems
2012 Problems
2011 Problems
2010 Problems
2009 Problems
2007 Problems
2006 Problems
2005 Problems
2004 Problems
2003 Problems
2002 Problems
2001 Problems
2000 Problems
1999 Problems
1998 Problems
1997 Problems
1996 Problems
1995 Problems
1994 Problems
1993 Problems
1992 Problems
1991 Problems
1990 Problems
Other FORD Models
'34
1500 Foldaway
A8513
A9513
A9522
Aerostar
Affordable Aluminum
Affordable Trailers
Aspire
AT8513
AT9513
AT9522
Similar Brands
ST
3,555 models
RS
3,484 models
NC
2,822 models
ND
2,385 models
Z
1,951 models
MOTO
1,583 models
NU
1,189 models
RC
1,122 models