How many problems does the 2016 FORD Fiesta have?

The 2016 FORD Fiesta currently has 178 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2016 FORD Fiesta?

The most common problems reported for the 2016 FORD Fiesta are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2016 FORD Fiesta problem data come from?

All problem and complaint data for the 2016 FORD Fiesta comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.

2016 FORD Fiesta Problems

POWER TRAIN

69 complaints

The transmission started slipping in 1st and 2nd gear.

Nov 12, 2025

The contact owns a 2016 Ford Fiesta. The contact stated while depressing the accelerator pedal, the vehicle failed to respond as intended and hesitated to respond. Additionally, the vehicle failed to reverse as intended. Several unknown warning lights were illuminated. The vehicle was taken to a dealer, where it was diagnosed that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided, and the contact was informed that the VIN was not under recall. The failure mileage was 70,000.

Aug 01, 2025

Symptoms: No-start condition (wouldn't crank w/o jump); delayed or harsh shifting; lost power (stalled going up tiny hill). Warning lights: transmission malfunction - service now; check engine light. Our symptoms and warning lights are consistent with Ford's Fiesta Transmission Control Module recall, however the VIN for our car is not part of the original recall. We meet all of Ford's recall eligibility criteria: reported before June 30, 2025; vehicle is less than 10 years old; vehicle has fewer than 150,000 miles. By virtue of the symptoms, warning lights and meeting Ford's other criteria strongly suggest our VIN should be included in the recall.

Jun 17, 2025

The contact owns a 2016 Ford Fiesta. The contact stated that while driving at various speeds, the transmission was slipping, causing the vehicle to lost motive power or stall. The contact was able to coast over to the side of the road and waited approximately 10 minutes before restarting the vehicle. The contact stated that several attempts were needed to restart the vehicle. The contact stated that the vehicle failed to restart intermittently. The contact stated that DTC: PO606 was displayed; indicating a failure with the Powertrain Control Module (PCM). The vehicle was taken to a certified mechanic who diagnosed and determined that the PCM had failed and needed to be replaced. The vehicle was not repaired. The contact found information about the Technical Service Bulletin: 16/0129 with the NHTSA ID Number: 10109047 (Power Train) and the Customer Service Program: 14M02 with NHTSA ID Number: 10057231 (Power Train); however, the vehicle was not included. The manufacturer was informed of the failure. The manufacturer transferred the contact to the NHTSA Hotline to report the failure. The failure mileage was 85,000.

Jun 09, 2025

The TCM was defective. It has been known that the TCM, transmission control modules are defective for Ford Fiestas and Focus. My daughter was driving the car and it stalled. If she was in heavy traffic are making a turn when this happened she could have been seriously injured. Ford said that they fixed this issue in the 2015 editions, that's why they stop the recall for 2016 models, but they really did not fix the problem. The vehicle was taken to a Ford dealership in Wisconsin and they confirmed all this information to me. And eight hundred dollars was paid to fix a problem that is on a recall for most models except the 2016, because they supposedly fixed the problem.

Apr 21, 2025

+ 64 more complaints for this component

ENGINE

11 complaints

Vehicle was traveling on an interstate highway when the oil indicator lamp lit, and the car immediately lost power, putting it in danger of being rear-ended. I researched any recalls and found "Part 573 Safety Recall Report 23V-905", which only covers two different models, the Focus and the Eco Sport, with precisely the same EcoBoost 1.0 Liter engine. I recently sent it to an independent service station to perform that which the recall describes, as a recall notice did not happen, but the service foreman stated it cannot be successfully repaired, as the oiling system was completely compromised, causing catastrophic damage to the valves, cylinders, turbo system, and vacuum pump.

Sep 18, 2024

The contact owns a 2016 Ford Fiesta. The contact stated while driving at approximately 30 MPH, and depressing the accelerator pedal, the vehicle failed to accelerate as intended and the vehicle started shuddering. The contact pulled over to the shoulder of the roadway to restart the vehicle, but the failure reoccurred. The messages "Mobilizer Malfunction" and "Engine Service" were displayed on the instrument panel. The local dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 138,000.

Apr 10, 2024

At 90,000 miles the Engine Timing Crankshaft Sprocket (i.e Crankshaft Gear,Part #: BE8Z6306AD) holding the timing belt on the vehicle has failed. This resulted in the timing belt backing off the cam gears and coming in contact with and melting through the plastic timing belt cover. Luckily, there was an audible grinding noise coming from the engine that alerted us the problem before the timing belt became dislodged. On further review there are numerous cases on the internet of this situation occurring. Please see examples at: [XXX] , [XXX] , and [XXX] . The service interval for this component established by Ford is 150,000 miles. Therefore, these situations represent an early failure of this engine component and poses a safety risk to drivers if the belt comes off track or breaks during operation because the vehicle could immediately lose power. The attached image shows the timing belt melting through the plastic timing cover. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Oct 20, 2023

I turned my car on July, 14, 2023 , I put my foot on the break to put in reverse, and when I put it in reverse it would not reverse and my brakes locked up and my car would start to roll forward while I was in reverse gear . My car drives forward but will not go in reverse and my engine light is not own. I took it two different shops , both with the same diagnois's , said it is my transmission and to contact Ford dealership directly for any possible recalls.

Jul 18, 2023

I should have an open recall for the coolant reservoir however it isn’t coming up at any Ford dealerships. There’s an issue with the OEM Khalid reservoir that comes in this vehicle and it’s leaking fluid.

Jun 03, 2022

+ 6 more complaints for this component

UNKNOWN OR OTHER

10 complaints

Transmision suddenly started making a grinding noise.

Jul 11, 2023

I bought my 2016 Ford Fiesta in 2019 at 49k miles. Since I have had my car, my car battery would die randomly and my car would fail to detect my key. Recently, when my car hit about 98k miles, my car died again and I needed to buy another new battery. Once the battery was replaced, the “service transmission now” sign began to show on the dash. My car will refuse to accelerate past 35 mph and will slow down to 0 mph. Found this out the hard way, on the freeway. My mechanic said I need a Transmission Control Module but the dealerships say the part I need is on back order. Another mechanic said the part itself is faulty and to NOT BUY another TCM. These are the following codes that returned on my car: P0606-00, P0702-00, UO401-00, UO131-00, UO420-86, UO101-00, UO140-00, U3003-16, UO193-00, U3006-16, V0427-68, B1007-94, UO121-87, VO127-87, UO140-87, B1C45-24, P0606 As of right now, there is no recall, so my car isn’t covered under the warranty. My 2016 Ford Fiesta was manufactured in November 2015.

Sep 14, 2022

Car stopped shifting in middle of highway. My safety was put at risk as it stopped moving on a busy road. Had to have towed to nearest shop, was told dual clutch system failed. Warning was “transmission malfunction service now”.vehicle is available for inspection, Ford refuses to compensate for faulty parts. Plenty of recalls for other models with same parts. Known issue for this model of vehicle per company and recalls from 3 years ago.

Sep 06, 2022

Car shutoff while driving on the highway

Jul 19, 2021

THE DRIVER SIDE DOOR LATCH FAILED. NO LONGER HOLDS THE DOOR CLOSED. WHEN CLOSED, THE DOOR CAN BE PUSHED OPEN FROM THE INSIDE WITHOUT TOUCHING THE DOOR HANDLE. THE CAR RECOGNIZES THE DOOR AS ALWAYS OPEN. THE VEHICLE WAS STATIONARY.

Feb 16, 2021

+ 5 more complaints for this component

POWER TRAIN,ENGINE

7 complaints

The contact owns a 2016 Ford Fiesta. The contact stated that the vehicle failed to reverse as needed. The contact stated that while driving, the vehicle was skipping third and fourth gears. The check engine warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the transmission control module needed to be replaced. The contact informed the dealer about the warranty coverage, but the vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 122,000.

Jan 05, 2024

The contact owns a 2016 Ford Fiesta. The contact stated that while driving at 50 MPH the engine began to smoke. The engine light was illuminated at the time of the failure. The vehicle was then towed to an independent mechanic. The vehicle was diagnosed with engine failure. The engine was replaced. The contact then stated that 4 months after while driving the contact was depressing the accelerator and the vehicle would not pass 5 MPH. The vehicle was then taken to an independent mechanic where it was diagnosed with transmission failure. The dealer was contacted and stated that next appointment was 2 months wait. The manufacture was not contacted. The failure milage was 86000. VIN tool confirmed no open recalls.

Dec 21, 2023

THE TCM LIGHT COMES ON WHEN CAR IS STARTED. WHILE THE CAR IS MOVING IT SEEM TO SLIP OUT OF GEAR. THIS HAPPENS WHILE DRIVING ON A STRAIGHT ROAD OR TURNING OR SLOWING DOWN. THE RPM REVS UP BUT THE CAR IS SLOWING DOWN. THIS HAPPENS WHEN DRIVING 30 MPH OR 50 MPH.

Feb 01, 2020

WHEN ACCELERATING AFTER STOPPING MY 2016 FIESTA SE SHUDDERS QUITE HARD MOVING FROM 1ST TO 2ND GEAR AND THEN ALSO FROM 2ND TO 3RD. I'VE NOTICED THAT THE LENGTH OF TIME THE CAR SHUDDERS IS INCREASING. THE SHUDDER IS ACCOMPANIED BY A LOUD RATTLING SOUND LIKE IF YOU SHOOK A BUNCH OF SCREWS IN A METAL CONTAINER. SOMETIMES LOSS OF POWER AND HIGH RPM'S OCCUR. I WILL TAKE IT BACK IN AND THIS WILL BE THE 4TH TIME. THE FORD DEALERSHIP TELLS ME THAT THE SHUDDER DOESN'T HARM THE TRANSMISSION. I DON 'T BELIEVE THAT. CAN'T EVEN SELL THE CAR (I TRIED) BECAUSE THIS CAR'S RESALE VALUE IS ZERO. NEXT I'M THINKING OF PURSUING A LEMON LAW RESOLUTION.

Jan 28, 2020

TL* THE CONTACT OWNS A 2016 FORD FIESTA. THE CONTACT STATED THAT THE ACTUATORS REPEATEDLY FAILED ON THE VEHICLE. IN ADDITION, THE AIR COMPRESSORS MALFUNCTIONED, WHICH CAUSED THE VEHICLE TO SHUT OFF WITHOUT WARNING. FURTHERMORE, THE VEHICLE LEAKED OIL FROM THE TRANSMISSION. THE CONTACT TOOK THE VEHICLE TO RUSSELL AND SMITH FORD (3440 S LOOP W, HOUSTON, TX 77025, (713) 230-8368) WHERE IT WAS SERVICED MULTIPLE TIMES FOR THE FAILURES UNDER WARRANTY. ON ONE OCCASION, WHILE THE VEHICLE WAS STOPPED AT A RED LIGHT, IT SHUT OFF WITHOUT WARNING. THE CONTACT ATTEMPTED TO RESTART THE VEHICLE, BUT THE ENGINE BEGAN TO SCREECH. UPON DEPRESSING THE ACCELERATOR PEDAL, THE VEHICLE CONTINUE TO SCREECH AND STALLED. THE VEHICLE WAS TOWED TO RANDALL REED'S PLANET FORD (19000 EASTEX FWY, HUMBLE, TX 77338, (866) 844-5995) WHERE THE VEHICLE WAS REPAIRED FOR THE AIR COMPRESSOR AND NUMEROUS OTHER FAILURES; HOWEVER, THE FAILURES CONTINUED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.

Oct 08, 2019

+ 2 more complaints for this component

ELECTRICAL SYSTEM

6 complaints

Odometer Fraud. The contact purchased a 2016 Ford Fiesta. The contact stated discovered that there was a mileage discrepancy after the purchase. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 110,000. It was later discovered that the actual mileage was 190,000.

Sep 22, 2025

My key battery apparently died and the whole car shut off in the middle of the forlane 75 mph. Had no breaks lights, or anything there Should be a warning sign or should let u keep driving to get off the road

May 21, 2024

The contact owns a 2016 Ford Fiesta. The contact stated that the ignition switched failed to respond after the key was placed in the ignition. The contact stated no warning light was illuminated. The contact had not taken the vehicle to a local dealer, where it was diagnosed and determined that the key needed to be replaced and a new key was cut. The vehicle had been repaired; however, the failure reoccurred. The manufacturer had been informed of the failure. The failure mileage was approximately 50,000.

May 01, 2023

PASSENGER SIDE WINDOW CONTROL DOES NOT WORK PROPERLY. BLUETOOTH AUDIO SOMETIMES PAUSES FOR NO REASON. CONDITIONS HAPPEN WHILE DRIVING OR STATIONARY.

Apr 22, 2020

THE HORN DOES NOT WORK. I NEVER TESTED THE HORN WHEN I TOOK THE CAR FOR A TEST DRIVE, AND ONLY DISCOVERED THIS FACT 2 WEEKS AFTER DRIVING THE VEHICLE.. THE DEALER CLAIMS THEY DID A THOROUGH SAFETY CHECK WHICH IS NOT THE CASE. I SIGNED THE 'SOLD AS IS' WAIVER SO I DON'T HAVE MUCH RECOURSE HERE, BUT THE DEALER SHOULD BE HELD ACCOUNTABLE FOR SELLING A VEHICLE THAT DOES NOT MEET THE BASIC SAFETY STANDARDS.

Nov 18, 2019

+ 1 more complaint for this component

WHEELS

5 complaints

Two years ago, a Ford Service person said 2 lug nuts needed to be replaced in order to rotate the tires. Later, I learned that this was a safety hazard because I would not have been able to change a flat tire. This time, I was told at the Ford dealer that all 16 needed to be replaced in order to rotate the tires. Also, I had to pay $110. to have this fixed. Once again, I was in danger of having a flat tire and being unable to remove the tire because of faulty lug nuts. This is a serious safety issue and should be recalled by Ford. I should also be reimbursed by Ford for this expense. No one should have to pay for replacing original Ford parts with parts that are still faulty.

Oct 24, 2022

The lug studs have "swollen" making it impossible to change a tire. I was told both by the tow truck driver who showed up to change the tire, and the tire shop where I took the car, that this is a known issue with this make/model and that you have to take it to a Ford dealership to be addressed.

May 16, 2022

Lug Nuts! They have swelled due to cheap product putting chrome over steel. Have to replace as mechanic can't get tires off. These could have cracked while driving, which would have put pressure on other lug nuts, maybe causing tires to fall off while driving. Being replaced with manufacturers lug nuts so it's going to happen again.

Mar 12, 2022

THE LUGNUTS SWELL AND THE LUG HUT WRENCH WITH THE CAR WILL NOT REMOVE THE LUG NUTS. MY WIFE GOT A FLAT TIRE, SHE WAS ALONE ON THE SIDE OF THE ROAD AND COULD NOT GET THE TIRE OFF BECAUSE THE WRENCH WOULD NOT FIT. THE ROAD SIDE SERVICE COULD NOT GET IT OFF ALSO. WE HAD TO GET THE CAR TO A SERVICE CENTER AND THEY HAD TO HAMMER A LARGER SOCKET ON IT TO BACK THE NUTS OFF. THEY SAY THIS IS A COMMON PROBLEM. REALLY? A COMMON PROBLEM THAT LUG NUTS FAIL??? THIS IS NOT RIGHT. I CALLED THE FORD DEALERSHIP AND THEY SAID SORRY BUT THERE IS NOTHING WE CAN DO. I CALLED FORD DIRECTLY AND THEY SAID THE SAME THING. POOR SERVICE.

Oct 30, 2020

TPS LIGHT STAYS ON. AIR LOSE IN FRONT DRIVER TIRE AND BACK DRIVER SIDE TIRE. I HAVE TO PUT AIR IN BOTH TIRES EVERY DAY. ABOUT 15 LBS OF AIR IN THE FRONT DRIVER TIRE AND ABOUT 8 LBS OF AIR IN THE BACK DRIVER SIDE TIRE

Jan 27, 2020

STEERING

5 complaints

While driving car suddenly jerked wheel out of drivers hands and almost pulled the car into a ditch on the right side. Lights on the dash say steering assist unavailable service now. There has been a recall on Ford cards with this EPAS system but somehow this system has still not been fixed and is going to kill more people if your agency keeps allowing it to not be a total recall on all vehicles with this system installed.

Feb 17, 2022

I HAVE REPORTED THIS PROBLEM BEFORE.. THE LEVER FOR THE ENGAGE/DISENGAGE FOR THE TILT TELESCOPIC WHEEL IS VERY HARD FOR ME TO ENGAGE I'M 76 & IT TAKES A LOT OF HAND STRENGTH TO MOVE IT UP & DOWN. I COMPLAINED TO THE SERVICE PERSON AT THE DEALER ABOUT THIS BUT SHE CLAIMED THEY COULDN'T TOUCH THAT IT'S A SAFETY ISSUE; WELL I KNEW ABOUT THE SAFETY & I'M NOT ASKING TO REMOVE THE LEVER JUST MAKE IT EASIER FOR ME TO USE... SO HERE I AM ONE YEAR LATER & MY HAND & THUMB ARE PERMANENTLY DAMAGED & THE PAIN IS HORRENDOUS.. ANOTHER DEFAULT OR DEFECT FROM FORD & IN ADDITION THIS VEHICLE SHOULDN'T EVEN HAVE BEEN ON THE LOT FORD HAD ALREADY NOTIFIED DEALERS ABOUT THE PROBLEMS WITH THE TRANSMISSION IN THESE MODELS SO NOW IN ADDITION TO THIS ISSUE I'M IN A CLASS ACTION LAWSUIT WITH THIS NEW CAR..

Dec 01, 2017

Injuries: 1

NOW SECOND OCCURRANCE OF A PROBLEM WITH THE POWER STEERING. POWER ASSIST FAILS ON STARTUP WITH CAR STATIONARY AND IN MOTION. BOTH TIMES THE CAR HAD BEEN PARKED IN COLD WEATHER FOR A FEW HOURS. UNASSISTED STEERING IS VERY HIGH EFFORT AND RENDERS THE CAR ALMOST UNUSABLE. THE FIRST TIME THIS OCCURRED THE DASH WARNING LIGHT WAS ON; DEALER SERVICE FOLLOW-UP HAD THE CAR FOR FOUR DAYS BUT FAILED TO TRACE THE PROBLEM OR DOCUMENT THE FAILURE CODE. DURING LAST OCCURRENCE THE WARNING LIGHT DID NOT APPEAR. IN BOTH CASES STOPPING AND RE-STARTING THE VEHICLE CAUSED THE POWER STEERING TO FUNCTION PROPERLY AGAIN.

Nov 28, 2017

I PICKED UP THIS FORD FIESTA 5DR VEHICLE 9/29/2016 (AUTOMATIC TRANSMISSION) NEW & AT THAT TIME I NOTICED THAT THE STEERING COLUMN LOCK/UNLOCK LEVER FOR THE TILT/ TELESCOPIC WHEEL WAS VERY HARD FOR ME TO ENGAGE/DISENGAGE TO ADJUST THE HEIGHT OF THE STEERING WHEEL.. I ASKED AT THAT TIME IF THE LEVER COULD BE ADJUSTED FOR EASE SINCE I AM A 76 Y/O FEMALE WITH NOT MUCH STRENGTH IN MY HANDS, PERHAPS IF I WERE A 20 Y/O AGILE MALE IT WOULDN'T BE SUCH AN ISSUE.. I WAS TOLD BY THE DEALER THAT THEY COULD NOT ADJUST THAT SINCE IT IS A SAFETY ISSUE TO CHANGE THAT; WHILE I UNDERSTAND THE SAFETY THING I ALSO KNOW THAT MY HAND, THUMB, ARM & WRIST ARE SUFFERING FROM THIS 'DESIGN FLAW' & I WILL SPEAK WITH MY DOCTOR NEXT WEEK IN REGARD TO THIS PAIN.. I'M NOT SURE WHO DESIGNED THIS LEVER TO BE SO HARD FOR SOME PEOPLE TO USE & ADJUST BUT OBVIOUSLY THEY DIDN'T TAKE INTO CONSIDERATION OLDER FEMALE DRIVERS .. WHILE I PAID FOR THIS FEATURE OF THE TILT/ TELESCOPIC WHEEL I'M HAVING A DIFFICULT TIME TAKING ADVANTAGE OF THIS FEATURE BECAUSE OF THE LEVER ISSUE; IN ADDITION I AM SHORT SO NEED TO GET CLOSER TO THE STEERING WHEEL TO DRIVE COMFORTABLY.. SHAME ON THE AUTO DESIGNER FOR WHAT I CONSIDER A DESIGN FLAW DONE WITHOUT TESTING BEFORE RELEASING TO THE ENTIRE PUBLIC..

Jul 13, 2017

STEERING WHEEL PLASTIC COVER CATCHES FINGER AT 5 O'CLOCK AND 7 O'CLOCK WHEN TRYING TO TURN. PLACING FINGER AND TURNING STEERING WHEEL CATCHES FINGER AND COULD LEAD TO AN ACCIDENT. PLASTIC STICKS OUT FROM THE BLACK BACK PLASTIC THAT IT TOUCHES. IN MY CAR IT'S A GRAY ACCENT U SHAPED THAT STARTS ON THE LEFT SIDE OF THE AIRBAG AND GOES DOWN AND AROUND TO THE RIGHT SIDE OF THE AIRBAG. THE TOUGH PART OF THE U-SHAPED GOES FROM THE LEFT AND YOU HAVE THE TELEPHONE BUTTONS RADIO BUTTONS ON ONE SIDE AND THEN YOUR CRUISE CONTROL BUTTONS ON THE OTHER IN THE CENTER OF THE TOP OF THE U-SHAP. DOWN ALONG THE BOTTOM WHEN IT TOUCHES THE OUTSIDE OF STEERING WHEEL THAT'S WHERE YOUR FINGER CAN GET CAUGHT WHEN TRYING TO TURN IT WHILE DRIVING. IF YOU REACH YOUR HAND IN THROUGH THE SMALL BOTTOM HOLES AND PULL OUT YOU CAN FILL THE EXTRA PLASTIC AND ALMOST A SHAPNESS DOWN ALONG THE BOTTOM WHEN IT TOUCHES THE OUTSIDE OF STEERING WELL THAT'S WHERE YOUR FINGER TO GET CAUGHT WHEN TRYING TO TURN IT WHILE DRIVING. IF YOU REACH YOUR HAND IN THROUGH THE SMALL BOTTOM HOLES AND PULL OUT YOU CAN FILL THE EXTRA PLASTIC AND ALMOST A SHARPNESS FROM IT .

Apr 04, 2017

POWER TRAIN,ELECTRICAL SYSTEM

4 complaints

The contact owns a 2016 Ford Fiesta. The contact stated while driving at an undisclosed speed, while the transmission was shifting between 1st and 2nd gear, the vehicle was shaking until the transmission had shifted to the higher gears. The contact stated that occasionally the vehicle failed to start intermittently. There were no warning lights illuminated. The vehicle had not been taken to the dealer. The vehicle had not been diagnosed or repaired. The contact also stated that the battery had been replaced by a friend approximately 7 times, and once by an O' Riley’s within the past 2 years. The manufacturer was made aware of the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 80,100

Sep 27, 2024

I BOUGHT MY 2016 FORD FIESTA WITH 31K MILES ON IT. AT THE TIME I DIDN'T RESEARCH TOO DEEPLY INTO THE TRANSMISSION ISSUES THESE MODELS HAVE. SINCE MY CAR HIT ABOUT 45K MILES I'VE EXPERIENCED SHUTTERING, JUMPING, CLICKING, AND ROUGH SHIFTING OR COMPLETE LACK OF SHIFTING IN THE TRANSMISSION WHILE DRIVING SAFELY AND NORMALLY. I'VE EXPERIENCED MY CAR DYING RANDOMLY BECAUSE THE TCM IS FAULTY AND USES ALL THE CAR'S POWER EVEN WHEN THE CAR ISN'T ON. DURING A PERIOD MY CAR WAS HAVING LOTS OF TROUBLE TURNING OVER THE ENGINE TO START. HAD A BUNCH OF VACUUMS AND WIRING REPLACED AND THIS HELPED A BIT WITH THE CAR STARTING. NOW IT'S AT 67K MILES AND I'M COMPLETELY SCARED TO DRIVE IT. IT NEVER FEELS RELIABLE GIVEN THE FAULTY TCM, I'VE HAD TO BUY AN EXTRA PORTABLE CAR JUMP STARTER JUST SO I CAN MAKE SURE I'LL BE ABLE TO DRIVE HOME, AND NOW I JUST WANT FORD TO BUY IT BACK. IT'S OVERALL A FAULTY CAR THAT IS FORESHADOWING A FUTURE OF REPLACING SOMETHING RELATED TO THE TRANSMISSION EVERY 5K MILES WHICH IS RIDICULOUS AND COMPLETELY UNAFFORDABLE. PLEASE REMEDY THIS CATASTROPHIC ISSUE FORD!

Feb 03, 2021

MY BATTERY WENT DEAD ON 5/26/20, IT WAS UNABLE TO BE JUMPED OFF AT AUTO ZONE. I BOUGHT A NEW BATTERY FOR $108. AFTER INSTALLING MY DASH APPEARED TRANSMISSION MALFUNCTION SERVICE NOW, PRIOR TO THIS I HAD NO ISSUES OTHER THAN MY PURGE CONTROL VALVE HAS WENT OUT TWICE. I CALLED THE DEALERSHIP AND HE IMMEDIATELY STATED THE BATTERY DYING CAUSED THE TRANSMISSION CONTROL MODULE TO BURN OUT AND THAT IT IS A COMMON ISSUE. HE SAID MY VEHICLE SHOULD HAVE BEEN INCLUDED IN A RECALL/EXTENDED WARRANTY BUT MY VINTAGE WAS NOT INCLUDED AND HE WASN'T SURE WHY. HE SAID IT WOULD BE A $600 FIX TO REACH OUT TO FORD MOTOR COMPANY ABOUT INCLUDING MY VEHICLE WHICH THEY REFUSED AFTER CALLING TWICE. I WAS AT AUTO ZONE WHEN THIS HAPPENED TO HAVE MY BATTERY TESTED BECAUSE 3 TIMES IN THE LAST MONTH I HAVE HAD TROUBLE STARTING MY CAR. I CALLED JENKINS AND WYNN IN CLARKSVILLE TN AS WELL AS FORD MOTOR COMPANY RECALL CUSTOMER RELATIONS TWICE. *BF*JB

May 27, 2020

CAR PARKED, BATTERY DEAD. JUMP STARTED CAR. CAR STARTED. ALL WARNING LIGHTS LIT ON DASH. ONLINE SEARCH RECOMMENDED DRIVING CAR TO RESET THE PROGRAMS. DROVE CAR AROUND BLOCK, CAR LOST ACCELERATION. FELT AS THOUGH TRANSMISSION WAS IN NEUTRAL. THE ENGINE REVVED WHILE GIVING GAS BUT WOULD NOT MOVE. TRANSMISSION MALFUNCTION WARNING LIGHT CAME ON. HAD CAR TOWED TO DEALERSHIP.

Sep 05, 2017

POWER TRAIN,VEHICLE SPEED CONTROL

4 complaints

Defected transmissions were installed on these cars. Ford recalled the least number with the least loss, but they kept the rest with their defected transmissions which cost more money than the car’s value. Ford sold their cars with defected transmissions and they knew it!

Apr 28, 2022

FORD DEALERSHIP "FIXED" THE TRANSMISSION ON 7-24-19 EXCEPT IT'S NOT FIXED. AT A STOP WHEN PRESSING THE GAS THE CAR WON'T MOVE THEN SUDDENLY LAUNCH FORWARD RANDOMLY. IT ALSO STILL LOSES ALL ENGINE POWER WHILE DRIVING DOWN THE ROAD. THESE WERE THE SAME SYMPTOMS AS BEFORE THE "FIX". THIS ISSUE HAS CAUSED A MINOR ACCIDENT AS WELL. WE GOT LIGHTLY REAR ENDED WHEN A LIGHT TURNED GREEN, WE STARTED MOVING FORWARD AND AT ABOUT 7-10MPH WE LOST ALL POWER AND THE PERSON BEHIND US COULDN'T STOP QUICK ENOUGH. DAMAGE WAS MINOR, JUST SOME CHIPPED PAINT BUT IT COULD HAVE BEEN MUCH WORSE.

Jul 27, 2019

Crash: 1

SINCE WEEK 1 THE CAR (WHEN AT A STOP AND IN GEAR) IF YOU PRESSED THE ACCELERATOR AT ANY LEVEL THE CAR WOULD DO NOTHING THEN AFTER ROUGHLY 3-6 SECONDS IT WOULD RANDOMLY LAUNCH FORWARD. IT WOULD ALSO SEEMINGLY GO INTO NEUTRAL ON THE HIGHWAY WHICH LED TO A COMPLETE LOSS OF ENGINE POWER. THIS ALSO HAPPENS WHEN ON A NORMAL ROAD AT ANY SPEED AND IS COMPLETELY RANDOM AND ONE TIME AT A RED LIGHT WE BEGAN TO ACCELERATE THEN POWER SUDDENLY CUT OUT AND WE GOT REAR ENDED LIGHTLY. I TOLD PETER'S FORD IN NASHUA NH DURING OUR 1ST 3 OIL CHANGES ABOUT THE ISSUE AND WAS TOLD IMPLICITLY THAT IT WAS COMPLETELY NORMAL AND I SHOULDN'T WORRY ABOUT IT AS IT WILL JUST GO AWAY ON ITS OWN. ESSENTIALLY I WAS BRUSHED OFF DESPITE 3 COMPLAINTS THAT NEVER LED TO THE DEALER CHECKING THE CAR. THESE ISSUES HAVE BEEN CONSTANT SINCE WE BOUGHT THE CAR BRAND NEW IN 2016.

Jul 24, 2019

Crash: 1

LUNGES FORWARD ANY TIME IT WANTS, ANYPLACE IT WANTS TOO.

Jul 16, 2019

FUEL/PROPULSION SYSTEM

4 complaints

ORIGINALLY, SINCE PURCHASE, EVERY TIME I FILLED UP THE VEHICLE IT WILL SUDDENLY JOLT OR JERK AND THE RPMS WOULD DROP TO THE HALF MARK THEN IT WOULD RUMBLE WHILE NOT IN MOTION. RECENTLY, THE VEHICLE HAS BEEN EXPERIENCING THE ABOVE ISSUES WHEN THE TANK IS NEAR EMPTY. I HAVE NOT NOTICED IT AT ANY OTHER TIME AS OF YET BUT I AM ASSUMING THAT IT WILL GET WORSE. FORD DEALERSHIP HAS TOLD ME IN THE PAST THAT THEY WILL NOT ATTEMPT TO DIAGNOSE THE ISSUE UNLESS THE ISSUE IS PRESENT DURING THERE CHECK IN PROCESS.

Apr 01, 2021

TL* THE CONTACT OWNS A 2016 FORD FIESTA. THE CONTACT STATED THAT THE CHECK ENGINE INDICATOR WAS ILLUMINATED. THE CONTACT NOTICED THAT EVERY TIME FUEL WAS PLACED IN THE TANK, THE VEHICLE SHUDDERED. ALSO, WHILE THE VEHICLE WAS STATIONARY, IT STALLED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE VACUUM FUEL LINE WAS UNABLE TO BLEED UP THE FUEL TANK VACUUM. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 88,298.

Oct 31, 2019

AFTER FILLING UP, THE CAR IDLES ROUGHLY. RPMS DROP UNEXPECTEDLY, AND SOMETIMES KILL THE ENGINE. THIS HAS RESULTED IN THE CAR SPORADICALLY DYING AT INTERSECTIONS WHILE IDLING AND WHILE SHIFTING INTO FIRST GEAR. THE CAR HAS BEEN DOING IT CONSISTENTLY AFTER FILLING UP WITH GAS. DOES NOT MATTER THE GAS STATION OR FUEL TYPE (87, 91, 93 OCTANE). NO CODES ARE THROWN AND DEALERSHIP HAS BEEN UNABLE TO DUPLICATE PROBLEM.

May 03, 2019

WHEN FUELING CAR WANT START WITHOUT DELAY. CODES P2196,P1450

Nov 04, 2018

POWER TRAIN,UNKNOWN OR OTHER

3 complaints

I have come to find that this vehicle suffers from premature slave cylinder failure, there are roughly 62,000 miles on the vehicle. Typical failure is reported to Ford between 70,000 and 80,000 miles. First symptoms appeared at roughly 58,000 miles. As I am a single father and a full time communications worker, I was not able to address this issue immediately upon discovering the initial symptoms as it would need further diagnosis. Clutch hydraulic fluids appear to be well sealed and clean. The design flaw with this system should be relatively obvious to a major automobile manufacturer such as Ford. The excessive temperatures caused by the transmission can and will affect any hydraulic systems severely. There are no avenues in which the temperatures can escape due to the bell housing of the transmission encasing the slave cylinder. In my experience as a prior automotive technician, most manual transmission automobiles place the cylinder in a more reasonable location, for example, beside the break booster in a 1991 Dodge Stealth. When observing the firewall in this location on this model of vehicle I can confidently say there is enough room to place a clutch slave cylinder in this location. The current placement appears to be for no other reason then planned obsolescence. Vehicle has stalled in traffic multiple times, cannot complete shifts due to clutch pedal sticking to floor. Inability to properly operate transmission as expected per mileage with a manual vehicle is a safety hazard. This is a safety concern due to limited ability to engage warning lights being that the shifter needs to be operated as well as the vehicle needing to be steered. Inability to depress the clutch to mechanical certainty limits the drivers ability to confidently navigate to a safe area to assess the vehicle's possible malfunctions. This limits the ability to warn other motorists on the roadways, which can cause accidents that may also cause injury/fatality depending on the speeds driven.

Oct 28, 2025

This car has a double clutch transmission that was done overseas evidently this car's transmission does not run right and I've had it tested out at a mechanic shop the transmission slips gears does not operate correctly I was told by the mechanic that is not a normal transmission it can cause an accident you put your foot on the gas the car will rev into the wrong speed stay keep the tachometer running in the red and could cause a serious accident to other people and that Ford will not fix it as it was manufactured incorrectly the first time this car is dangerous and now I'm stuck paying for a used car that could cause an accident Ford denies any culpability.

Jul 25, 2024

THE CLUTCH PEDAL GETS STUCK ABOUT AN INCH OFF THE FLOOR AFTER BEING DEPRESSED AT SEEMINGLY RANDOM TIMES USUALLY IN THE WARMER WEATHER MONTHS. THIS HAS CAUSED ME TO LOSE THE ABILITY TO CHANGE GEARS AND LOSS OF ABILITY TO ACCELERATE. IT DOES NOT COME OUT OF THIS POSITION UNTIL I PHYSICALLY PULL THE PEDAL OFF THE FLOOR. I HAVE HAD INCIDENTS WHERE I HAVE BEEN STUCK IN THE MIDDLE OF AN INTERSECTION UNABLE TO MOVE WHERE I HAVE ALMOST BEEN HIT BY ONCOMING TRAFFIC. THIS IS NOT AN UNCOMMON ISSUE AND IS NOTED IN MANY FIESTA ST FORUMS.

Jul 24, 2020

ELECTRICAL SYSTEM,ENGINE

3 complaints

Customer satisfaction program 16B11 covers a faulty high speed cooling fan relay. This bulletin was issued on April 5, 2016. I purchased the vehicle on [XXX]. An incorrect relay was installed at the factory, and the program should have replaced the relay with the correct part. This was not performed on my vehicle before I purchased it from Sheehy Ford of Ashland. The faulty relay failed, melting the fuse box in the process and causing the vehicle to overheat and cause permanent severe engine damage. Remnants of the melted relay show the part number, which matches the obsolete part number. Visual comparison of the faulty relay matches the obsolete part as well, and differs from the correct superseded part number relay outlined in the 16B11 bulletin. Ford Motor Company insists my vehicle was not a part of this program and any repairs will not be covered. The build date, make/model/engine, assembly plant and most importantly, part number of the relay and mode of failure exactly match the 16B11 CSP bulletin. Ford denies that there is any issue with my vehicle. Local Ford dealers refer me to Ford Motor Company to escalate this problem, but Ford refuses to investigate. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Jul 02, 2025

I HAVE A 2016 FORD FIESTA THIS MODEL CAR DOES NOT COME WITH A GAS CAP. I'VE NOTICED AFTER I FILLED MY CAR UP WITH GAS MY CAR STUTTERS AND STALLS OUT AND SOMETIMES DOESN'T START RIGHT AWAY THIS GOES AWAY AFTER 3 OR 4 TIMES IS STARTING THE CAR BACK UP I TOOK IT TO THE DEALERSHIP AND THEY TOLD ME THAT MY PURGE VALVE FOR THE FORD FIESTA WAS DEFECTIVE I'VE ALREADY HAD THIS REPAIRED AND BELIEVE THIS REPAIR HAS FIXED THE PROBLEM I'VE READ OF OTHER PEOPLE OF THE SAME YEAR MAKE AND MODEL HAVING SIMILAR ISSUES APPARENTLY BECAUSE THE HAS A CAPLESS GAS TANK THIS CREATES AIR POCKETS IN THE FUEL TANK WHICH MESSES UP THE PURGE VALVE OVER TIME.

Feb 04, 2021

TL* THE CONTACT OWNED A 2016 FORD FIESTA. WHILE DRIVING 60 MPH, FLAMES APPEARED UNDER THE HOOD OF THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD. WHEN HE EXITED THE VEHICLE AND OPENED THE HOOD, THE CONTACT NOTICED FLAMES BETWEEN THE BATTERY AND THE ENGINE. THE VEHICLE WAS DESTROYED. THERE WERE NO INJURIES. A POLICE REPORT WAS NOT FILED. THE MANUFACTURER AND DEALER HAD NOT BEEN CONTACTED. IT WAS UNKNOWN IF THE FIRE DEPARTMENT WAS CALLED TO EXTINGUISH THE FIRE AND IF THE VEHICLE WAS TOWED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 23,500.

Jun 06, 2018

Fire: 1

POWER TRAIN,FUEL/PROPULSION SYSTEM

3 complaints

I was in Michigan and my car, which had been in great shape, unexpectedly failed to start after sitting for two days. After jump-starting the battery, the maintenance light turned on and my display showed a transmission malfunction. So while I traveled in my car to Columbus, unaware of the potential danger that my car could catch fire and explode because it couldn't shift beyond third gear, I stopped at AutoZone for an inspection where the man informed me about a specific error code called P0606. The car dealership, Holmes Motors, was well aware of the issues with my car because we had informed them about another defective Ford Fiesta they had in stock. However, they made a deliberate decision not to reveal any of this important information to me or my family. I’ve been had problems when my car failed to start after refueling last year. One of the two main issues I've encountered with Them. Firstly, they advised me that they had repaired my vehicle; that was not the case. Secondly, they never upheld the warranty and argued that my recurring issue was not eligible for coverage, after they just worked on it. The other Ford Fiesta that we saw coincidentally ended up being my ex-roommate's car, and it still had the same problems. At AACMO in Columbus, They confirmed that my dual clutch assembly transmission had malfunctioned and overwhelmed my TCM. This exact same incident was also mentioned in the lawsuit filed against Ford, and from numerous people who faced the same issue. I’m stuck in Ohio with insufficient funds for repairs or a replacement, which means I have no way home and zero source of income to sustain myself. It sucks that the entire burden of repairs falls on us while these companies neglect to accept any accountability for their faults. Has not been brought to the manufacture yet. If there is any other actions to help assist in my situation, please feel welcome to contact me. Thank you.

Jun 30, 2023

TAKATA RECALL. EVERY TIME I PUT FUEL IN MY CAR IT HESITATES. SOMETIMES IT CUTS OFF AND SOMETIMES IT JUST SHAKES AND ALMOST CUTS OFF. IT HESITATES WHEN I DON'T PUT FUEL IN IT BUT IT DOES IT WORSE EVERYTIME I PUT FUEL IN IT. THE TRANSMISSION DOESN'T CHANGE GEARS SOMETIMES. I HAVE TO LET IT COAST TO GET IT TO CHANGE GEARS OR I HAVE TO STOP THEN GO. IF I YIELD THEN GO WITH OUT COMPLETELY STOPPING THE TRANSMISSION WON'T CHANGE GEARS UNLESS I LET IT COAST UNTIL IT CHANGES OR STOP AND LET IT CHANGE BEFORE I PROCEED.

Mar 19, 2019

THE CAR WILL NOT START PROPERLY AFTER REFUELING. YOU HAVE TO PRESS ON THE GAS SEVERAL TIMES AND THEN THE BRAKE TO START IT. WHEN IT DOES START, YOU NEED TO REV THE ENGINE A COUPLE TIMES TO MAKE SURE IT WON'T DIE AGAIN. THE TRANSMISSION IS NOW SLIPPING AND DROPS TO NEUTRAL WHILE DRIVING AT ANY GIVEN TIME. IT HAPPENED TO ME TWICE THIS MORNING WHILE DRIVING ON THE INTERSTATE. WHEN IT FINALLY GETS BACK INTO GEAR, IT LURCHES FORWARD. THIS MORNING I WAS NEARLY IN AN ACCIDENT BECAUSE OF THIS NEW DEVELOPMENT IN A 2 YEAR OLD CAR. I WILL NEVER BUY A FORD AGAIN, THIS IS TOO DANGEROUS FOR ANYONE VALUING THEIR LIVES.

Nov 09, 2018

SUSPENSION

3 complaints

WHILE DRIVING I HEAR LIKE A KNOCKING NOISE COMING FROM THE FRONT END, WHILE DRIVING DOWN MAIN STREETS AND SIDE STREETS.

Feb 02, 2020

REAR PASSENGER STRUT SNAPPED ON 5 HOUR HIGHWAY DRIVE. WHEN LIFTED AT THE GARAGE IT WAS DISCOVERED THAT WOOD SCREWS WERE USED TO SECURE THE STRUT BRACKETS INSTEAD OF BOLTS. ONE OF THE SCREWS HAD ALREADY FALLEN OUT OF THE STRUT THAT HAD SNAPPED AND ON THE REAR DRIVERS SIDE, ONE OF THE WOOD SCREWS USED WAS LOOSE AND HALF WAY OUT. THE TYPE OF SCREWS USED WERE WRONG BECAUSE THERE WAS NOTHING TO TIGHTEN THEM OR HOLD THEM IN PLACE SECURELY AS A BOLT WITH A NUT WOULD AND THEY TURNED AND LOOSENED AS VEHICLE WAS DRIVEN. 2016 PURCHASED FROM A DEALERSHIP ON 9/7/2019 WITH 30K MILES.

Jan 16, 2020

NOISE FROM RIGHT FRONT STRUT AREA. VERIFY NOISE FROM OUTSIDE STRUT FOUND TO BE LEAKING PASS SIDE STRUT LEAKING. REPLACE STRUT AND HARDWARE.

Aug 01, 2019

ELECTRICAL SYSTEM,STRUCTURE

2 complaints

Trunk latch releases randomly. Like so many other people with this generation of Ford Fiesta. They have taken them in for the same issue and told they don't by the shop that they don't know what the problem is. The problem is random so getting to to happen while at the shop is next to impossible. If the problem can't be reproduced by a garage mechanic, how would Insurance, or police have any luck? There needs to be a recall, because some people are having them pop open while driving at night, and all of a sudden the interior lights come on, safety hazard!!! Some will pop open and kill the battery because the dome light comes on when the trunk opens. Then you're standing in subzero temperatures trying to jump start the car. That in and of itself is a safety issue. No warning lights are associated with this.

Jan 16, 2025

MY TRUNK POPS OPEN ON ITS OWN. AT LEAST 3 TIMES A DAY AT RANDOM. GIVING ACCESS INTO THE VEHICLE. THIS HAPPENS WHILE I'M DRIVING AND WHILE THE CAR IS STATIONARY. I HAVE WOKEN UP AT 4 AM AND MY TRUNK BE OPEN. I'VE BEEN DRIVING AT 60MPH AND THE TRUNK OPEN. BEEN IN A DRIVE THROUGH AND THE TRUNK OPEN. THIS HAS BEEN GOING ON FOR MONTHS. MY SON SEEN THE TRUNK WAS OPEN AND SHUT IT REPEATEDLY JUST FOR IT TO OPEN EVERY FEW MINUTES. THIS IS A COMMON ISSUE WITH THESE AND SIMILAR FORD VEHICLES.

Aug 25, 2020

STRUCTURE

2 complaints

The contact owns a 2016 Ford Fiesta. The contact stated that upon inspection, it was discovered that there was rust on the roof of the vehicle around the base of the antenna. The local dealer was contacted, but the vehicle was not diagnosed or repaired due to the VIN not being included in an unidentified recall. The manufacturer was made aware of the failure. The failure mileage was approximately 45,000.

Aug 21, 2024

The contact owns a 2016 Ford Fiesta. The contact stated that while driving at an undisclosed speed, the front windshield and the windows became foggy, causing poor visibility of the roadway. The contact opened the rear liftgate door and noticed that the spare tire well was filled with water. The vehicle was taken to the dealer, where it was determined that water was leaking into the rear of the vehicle from the rear liftgate door. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 74,000.

Apr 12, 2023

POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE

2 complaints

The contact owns a 2016 Ford Fiesta. The contact stated that the transmission was not working as designed. While driving at various speeds, the vehicle accelerated abruptly. While changing gears at low speed, the vehicle was shaking and shuddering. While driving approximately 30 MPH, the RPM raised up to 3,000 RPM. While attempting to accelerate from a stop, the vehicle failed to move. Additionally, while depressing the brake pedal, the vehicle accelerated. The check engine warning light was illuminated. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The vehicle was previously taken to the local dealer where it was diagnosed that a vapor valve replacement was needed. The vehicle was repaired but the failure persisted. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 112,000.

May 02, 2023

WHILE DRIVING ON THE HIGHWAY MY CARS THROTTLE BODY STOPPED FUNCTIONING. HAVING TO TRY AND PULL OVER I GOT STUCK IN THE MIDDLE OF TRAFFIC. I SHUT THE CAR OFF AND STARTED IT AGAIN AND EVERYTHING SEEMED FINE. DURING THE SAME TRIP HOME I GOT STUCK ON A SMALL TWO LANE BRIDGE TWICE FOR THE SAME REASON. AFTER GETTING OFF THE BRIDGE IT HAPPENED A FOURTH TIME ON THE HIGHWAY AGAIN DOING 70MPH.

Apr 07, 2021

POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

2 complaints

2016 ford fiesta se has had a transmission/clutch problem. It is doing everything that the recall says it's suppose to cover and Ford is not willing to honor and fix it. It's jerking, shaking, and not accelerating properly.

Feb 22, 2023

MY CAR HAS LESS THAN 50000 MILES AND ALREADY BEEN TO THE SHOP DUE TO NOT STARTING. IT WAS DETERMINED THAT THE BATTERY HAD A BAD CELL. GOT THE BATTERY REPLACED AND ALL WORKED FINE. 2 MONTHS LATER THE SAME ISSUES ARE HAPPENING AGAIN. WILL GO TO THE SHOP THIS WEEK. HOPEFULLY THEY VAN FIND OUT WHAT'S WRONG.

Aug 20, 2018

ELECTRICAL SYSTEM,UNKNOWN OR OTHER

2 complaints

On Sunday December 4th 2022 my car battery died. I called aaa and they sent out a tow company to jump the battery. I noticed for about a month the car made a "ticking" noise. The noise would sound like a "sighing" when parking the vehicle. The passenger side door latch is broken and will no longer lock my door. My minor daughter used to sit up there but now because the door flys open she can no longer sit there. This is a serious safety hazard and needs to be recalled on Ford Fiesta 2016 as well.

Dec 07, 2022

OVER THE SUMMER 2019, PASSENGER LEFT SIDE DOOR DID NOT LATCH. CHILD LOCK WAS ON. UPON DISCOVERY OF DEFECT, IT WAS TAKEN TO FORD TO REPAIR. ON NOVEMBER 12, 2019, DRIVER'S SIDE DOOR DID NOT WANT TO LATCH. WENT TO CHECK ON THE CAR NEXT DAY, AND THE DOOR LATCHES WITHOUT PROBLEMS MORE THAN ONCE. FILING A COMPLAINT BECAUSE IT HAS HAPPENED TWICE IN THE SAME YEAR WITH DIFFERENT CAR DOORS. WILL TAKE TO FORD AGAIN ON NOVEMBER 15TH TO HAVE IT LOOKED AT TO MAKE SURE THERE ARE NO ADDITIONAL PROBLEMS WITH THE CAR. BOTH TIMES THE VEHICLE WAS STATIONARY WHEN THIS OCCURRED.

Nov 13, 2019

SEAT BELTS

2 complaints

THE 2016 FORD FIESTA SEATBELT DOES NOT RETRACT PROPERLY AND THE SEATBELT HANG TO THE DRIVER SEAT WHILE THE SEATBELT METAL BUCKLE POINTING UP AND THE DRIVER COULD SAT TO IT AND INJURED THE BACK RIBS OF THE DRIVER JUST LIKE HOW I INJURED MY SELF BECAUSE OF LACK OF WARNINGS FROM OWNERS' MANUAL FROM FORD MOTOR THAT THESE SEATBELT PROBLEM SHOULD HAVE BEEN FORSEABLE BY THE MANUFACTURED TO WARNED THE CONSUMERS.

Sep 26, 2022

Crash: 1

Injuries: 2

The contact owns a 2016 Ford Fiesta. The contact stated the seat belt does not retract on the driver's side and passenger side. The contact stated he sat on the buckle and injured himself. The contact has been seeing a chiropractor for 3 years now. The contact did not take the vehicle to a dealer nor was the seat belt repaired. The manufacturer was notified. The failure mileage was 51,617.

Apr 27, 2022

Injuries: 1

ENGINE,FUEL/PROPULSION SYSTEM

2 complaints

RECENTLY AT 48,000 MILES MY CHECK ENGINE LIGHT CAME ON FOR A CODE P1450 AND P0456 WHICH IS FOR THE EVAP SYSTEM. MY VEHICLE NOW STALLS WHEN GAS IS FILLED UP AND EVEN LOSES PERFORMANCE AT HIGH SPEEDS.

Apr 18, 2019

WHILE IDLING AT STOP LIGHTS OR CITY DRIVING THE CAR WILL DROP RPM'S OR STALL OUT ON IT'S OWN. HAS HAPPENED WHILE MAKING A U-TURN, TURNING, AND IDLING. IT HAPPENS RANDOMLY AND FORD WILL NOT TAKE THE ISSUE SERIOUSLY

Oct 29, 2018

POWER TRAIN,ENGINE,ELECTRICAL SYSTEM

1 complaint

The contact owns a 2016 Ford Fiesta. The contact stated while driving approximately 60 MPH, the vehicle was losing motive power. The check engine warning light was illuminated. The vehicle was taken to the dealer to be diagnosed and it was determined that the spark plugs needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the same dealer who diagnosed the vehicle and determined that the ignition coils needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken to an independent mechanic who diagnosed the vehicle and determined that the TCM needed to be replaced. The vehicle was not repaired. The contact researched online and related the failure to Customer Satisfaction Program: 14M02 (Power Train); however, the VIN was not included. The manufacturer was informed of the failure and referred the contact to NHTSA Hotline to report the failure. The failure mileage was approximately 130,000.

Jul 24, 2025

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

1 complaint

The contact owns a 2016 Ford Fiesta. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The check engine warning light was illuminated. The contact stated that the failure persisted. The vehicle was taken to an independent mechanic; however, no cause for the failure was found. The mechanic informed the contact that it was possibly the battery and the key fob battery that had caused the issues. The contact took the vehicle to the dealer where the key fob battery was replaced. The contact replaced the battery independently. The check engine warning light was illuminated. The manufacturer was not notified of the failure. The failure mileage was unknown.

Jul 16, 2025

ENGINE AND ENGINE COOLING

1 complaint

The contact owns a 2016 Ford Fiesta. The contact stated that while operating the vehicle, there was a continuous swishing sound coming from the engine compartment. The vehicle was taken to the local independent mechanic who diagnosed the vehicle and determined that the water pump was faulty and needed to be replaced. The water pump was replaced. The local dealer and manufacturer were not yet notified of the failure. The failure mileage was 74,000.

May 15, 2025

VISIBILITY

1 complaint

The contact owns a 2016 Ford Fiesta. The contact stated that while starting the vehicle, the dashboard made abnormal clicking sounds. The contact stated that the air inlet blend door actuator had previously been replaced; however, the failure recurred. The vehicle was taken to the dealer, where it was diagnosed that the air inlet blend door actuator needed to be replaced for the second time. The dealer replaced the air inlet blend door actuator. The manufacturer was made aware of the failure and a case was opened. The failure mileage was 57,183.

Apr 12, 2024

POWER TRAIN,SERVICE BRAKES

1 complaint

The contact owns a 2016 Ford Fiesta. The contact stated while driving approximately 35 MPH and descending a grade in the road, the contact attempted to depress the brake pedal to slow down however, the brake pedal went to the floorboard. The contact had to pump the brake pedal to slow the vehicle. The contact stated that the check brakes warning light was illuminated. Additionally, the contact stated that there were also mechanical issues with the transmission. The vehicle could not be shifted into reverse (R) and while the vehicle was in drive (D), the vehicle would hesitate while shifting gear. The contact took the vehicle to a local dealer who diagnosed the vehicle and determined that the clutch needed to be replaced. The vehicle was not repaired. The contact stated that the dealer had not diagnosed a failure with the brakes. The manufacturer was informed of the failure. The failure mileage was approximately 79,000.

Feb 15, 2024

STRUCTURE,LATCHES/LOCKS/LINKAGES

1 complaint

Its the third time i find the hud of my car open! I was driving in the city and the speed was under 25 mph when i found out , im just concerned if im driving in a highway and that happens!

Apr 30, 2023

LATCHES/LOCKS/LINKAGES

1 complaint

The contact owns a 2016 Ford Fiesta. The contact stated while opening the passenger’s side front door, she felt excessive play in the door handle. While attempting to close the door, the door failed to latch securely. The contact was able to secure the door using bungie cords. The contact drove the vehicle to a dealer where it was diagnosed that the latching mechanism was defective. The vehicle had not been repaired. The manufacturer had not been informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 20V331000 (Latches/Locks/Linkages). The failure mileage was approximately 63,000.

Dec 28, 2022

SUSPENSION,ENGINE

1 complaint

New vehicle was sold with 2 manufacturing defects: 1) Defective front left shock absorber with made steering unstable. 2) Leaking value cover gasket with created a fire risk. 3) Both defects where confirmed by a dealer. 4) Vehicle has not been inspected by manufacturer, police, insurance representative or others. 5) No warning lamps, messages or other symptoms of problem were presented prior to first dealer inspection. 6) The dealer who discovered the 2 manufacturing defects within the 3 year warranty period, held the vehicle over the weekend and claimed to have fixed both. However the next time I took it to a service center I was told the value cover gasket was leaking. 7) I eventually returned to the original dealer who sold me the vehicle and they confirmed that the value cover gasket was leaking and apparently was not repaired under warranty as expected. 8) The original dealer repaired the value cover gasket off-premise in local parking lot and over charge me based on previous warranty price.

Dec 13, 2022

POWER TRAIN,FORWARD COLLISION AVOIDANCE

1 complaint

Transmission control module failed and driving is unsafe as lurching pick up in traffic and complete failure of transmission. No reverse or forward gear.

Jun 03, 2022

AIR BAGS

1 complaint

The contact owns a 2016 Ford Fiesta. The contact stated while his girlfriend was driving at 45 MPH with him in the front passenger seat, another vehicle suddenly crossed in front of the vehicle, causing the vehicle to crash into the rear end of the other vehicle. The front driver's side air bag and the passengers' side air bags failed to deploy. The driver's knee air bag deployed. There was no warning light illuminated. The contact's girlfriend sustained neck injuries and leg injuries and was transported to the hospital by emergency units. The contact sustained soreness on the right knee and stomach. The contact sought medical assistance the next day. A police report was filed. The vehicle was towed to a tow lot. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure but did not provide any assistance. The manufacturer referred the contact to NHTSA. The failure mileage was approximately 145,000.

May 25, 2022

Crash: 1

Injuries: 2

AIR BAGS,SEAT BELTS,SEATS

1 complaint

My Ford fiesta suddenly exploded the seat's ventilation and my seatbelts tore off, so i crashed into a semi at the speed of 191 km/h

Feb 01, 2022

Crash: 1

Injuries: 3

ELECTRICAL SYSTEM,STRUCTURE,UNKNOWN OR OTHER

1 complaint

Alarm is constantly going off which means I don't know if it's a real intruder or just the door ajar switch, recall affected up until 2015 but the issue keeps going into 2016 ford fiestas, this is a safety issue as we cannot tell if someone is breaking into the car

Nov 05, 2021

UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM

1 complaint

WHEN FUEL IS ADDED TO THE VEHICLE, IT WILL NOT START FOR 5-20 MINUTES AFTER FUEL IS ADDED AND REQUIRES 3-5 ATTEMPTS TO START. ADDITIONALLY, THERE HAVE BEEN TIMES WHERE ONCE IT STARTS AND BEGINS OPERATING, IT WILL LOSE POWER AND SHUT OFF. THIS POWER LOSS HAS OCCURRED MULTIPLE TIMES AFTER LEAVING THE GAS STATION PARKING LOSS, LEADING TO BEING STALLED WHILE IN MOTION ON A ROADWAY. THIS IS A INCREDIBLY SCARY EXPERIENCE.

Mar 03, 2021

SEAT BELTS,STRUCTURE,UNKNOWN OR OTHER

1 complaint

MY VEHICLE IS A 2016 FORD FIESTA ST WITH A SUNROOF. I LIVE IN AN AREA WHERE THERE IS NOT MUCH FLAT LAND TO PARK VEHICLES. MY DRIVEWAY IS GREATER THAN A 20% GRADE. THIS COMPLAINT IS RELATED TO SUNROOF SEAL LEAKS IN ANY MODE OF OPERATION. THE SUNROOF SEAL IS A SINGLE STRIP OF RUBBER WITH A DISCONNECTED SEAM THAT IS ORIENTED AT THE TOP OF THE SUNROOF. AS THE RUBBER AGES, THE RUBBER SHRINKS AND THE SEAM CAN DEVELOP INTO A GAP THAT LETS WATER INSIDE THE SUNROOF DRAINAGE TRAY. IF THE SUNROOF SEAL LEAKS OR FAILS, THE CAR IS DESIGNED TO COLLECT THE WATER AND DRAIN IT TO A LOCATION NEAR THE FRONT WHEEL WELLS. THIS WORKS PERFECTLY AS LONG AS THE CAR IS LEVEL. IF THE CAR IS PARKED AT A 15% GRADE OR STEEPER WITH THE FRONT OF THE VEHICLE POINTING UPWARDS, THE SUNROOF SEAL WILL LEAK, BUT THE WATER COLLECTED WILL NOT DRAIN TOWARD THE INTENDED DRAINS. THE WATER WILL INSTEAD FLOW DOWN THE SIDES OF THE ROOFLINE INSIDE PLASTIC TROUGHS. THESE TROUGHS ARE NOT WELL DRAINED TO THE EXTERIOR. THE WATER WILL FLOW THROUGH THE TROUGHS AND EXIT INTO THE INTERIOR OF THE VEHICLE NEAR THE HEAD LINER AND THE REAR PLASTIC TRIM OF THE INTERIOR NEXT TO THE REAR WINDOW. THIS WILL EVENTUALLY FILL UP THE SEALED SPARE TIRE WELL, AND WILL CAUSE CORROSION OVER TIME. THIS CORROSION MAY AFFECT THE CAR'S STRUCTURAL INTEGRITY AND MAY AFFECT THE CAR'S CRASH WORTHINESS IF ALLOWED TO CONTINUE. THE WATER IS ONLY NOTICEABLE IF THE TRUNK SHELF IS REMOVED, WHICH IN MANY VEHICLES WILL NEVER HAPPEN. THE WATER ALSO HAS A TENDENCY TO COLLECT ON THE REAR SEATBELT SPOOL AND THE SPOOL SUPPORT FASTENERS. IF THE WATER IS LEFT ON THE SEATBELT SPOOLS FOR LONG ENOUGH TIME, THE SEATBELTS FOR THE REAR SEATS CAN BE WEAKENED OVER TIME BY CORROSION. THE SEATBELT ISSUE MAY NOT BECOME A SAFETY CONCERN UNTIL SOMETIME IN THE CAR'S FUTURE IN THE SECONDHAND MARKET. BLACK MOLD GROWTH MAY BECOME AN ISSUE AS WELL.

Apr 24, 2020

ELECTRICAL SYSTEM,EXTERIOR LIGHTING,UNKNOWN OR OTHER

1 complaint

TUVE PROBLEMA CON LA COMPUTADORA Y TRANSMISIN AUTOMTICA, DESDE QUE SE ADQUIRI LA UNIDAD REPORTE PROBLEMA CON LOS ELEVADORES DEL AUTO YA QUE NO SE TRABAN A SUBIR Y BAJAR, NO HAN DADO SOLUCIN A ESTE PROBLEMA Y SOLO LO 'RESUELVEN CON LUBRICANTE' . LA INTENSIDAD DEL TABLERO CAMBIA CONSTANTEMENTE, AL TRATAR DE SUBIR O BAJAR EL VOLUMEN DEL ESTERO NO LO HACE DE MANERA CORRECTA

Mar 11, 2020

AIR BAGS,SEAT BELTS,STRUCTURE

1 complaint

I WAS INVOLVED IN AN ACCIDENT ON THE FREEWAY THE VEHICLE WAS STRUCK TWICE AND CAREENED INTO THE CENTER DIVIDER ONCE BEFORE COMING TO REST. THE AIRBAGS NEVER DEPLOYED. I SUSTAINED A BROKEN NECK BY HYPER EXTENDING MY NECK OVER THE STEERING WHEEL.

Feb 23, 2020

Crash: 1

Injuries: 1

UNKNOWN OR OTHER,ELECTRONIC STABILITY CONTROL (ESC),ENGINE

1 complaint

WE TRIED TURNING THE CAR ON. THE LIGHTS STARTED BLINKING RAPIDLY THE. IT SAID THE TRACTION CONTROL WAS OFF. EVEN THOUGH WE DID NOT TURN IT OFF. WE JUMP STARTED THE CAR AND IT WENT ON BUT ONLY FOR THE DASHBOARD TO SAY 'TRANSMISSION MALFUNCTION SERVICE NOW'. WHEN DRIVING ON THE STREET AND FREEWAY TO THE NEXT EXIT. IT FELT AND SOUND LIKE THE ENGINE IS REVVING THE ENTIRE TIME NO MATTER WHAT SPEED. THE RPM IS RUNNING HIGH GOING STRAIGHT PAST 3

Dec 10, 2019

ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

WHEN I REFUEL IT TAKES SEVERAL TRIES TO GET VEHICLE RESTARTED AND NEED TO PUMP ACCELERATOR TO KEEP IT FROM DYING. THE SMELL OF GAS IS BAD. COME TO A RED LIGHT STALLS AND HARD TO RESTART. AIR BAG LIGHT ON DASH AND NEVER GOES OUT. RPM SURGE AND CAR WILL LUNGE, VERY SCARY. JUST STARTED A LOUD CLICKING/THUMPING NOISE, FOUND OUT COULD BE ACTUATOR. AC WILL STOP BLOWING COOL AND BEGIN AGAIN. REPAIR SHOP CAN'T FIGURE OUT WHY. FOR A NEW CAR HAS MANY ISSUES FOR BEING OUT FOR SUCH A SHORT TIME.

Aug 04, 2019

POWER TRAIN,VEHICLE SPEED CONTROL,SERVICE BRAKES

1 complaint

TL* THE CONTACT OWNS A 2016 FORD FIESTA. WHILE DEPRESSING THE BRAKE PEDAL, THE VEHICLE CONTINUED TO LUNGE FORWARD WITHOUT WARNING. AT TIMES, WHILE APPLYING PRESSURE TO THE ACCELERATOR PEDAL, THE VEHICLE WOULD STALL AND THEN SLOWLY PICK UP SPEED. THERE WERE NO WARNING INDICATORS ILLUMINATED DURING THE FAILURES. THE CONTACT ALSO STATED THAT THE VEHICLE SHIFTED INTO NEUTRAL WHILE IN DRIVE, WHICH CAUSED THE VEHICLE TO OVERHEAT WITHOUT WARNING. THE VEHICLE WAS TAKEN TO GALPIN FORD (1000 SANDRETTO DR, PRESCOTT, AZ 86305, (877) 826-2935) WHERE IT WAS DIAGNOSED WITH A FAULTY TRANSMISSION. SINCE OWNING THE VEHICLE, THE CONTACT HAD THE TRANSMISSION CONTROL MODULE REPLACED TWICE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES AND PROVIDED THE REPAIR COST. THE FAILURE MILEAGE WAS 39,000.

Jul 25, 2019

POWER TRAIN,UNKNOWN OR OTHER,ENGINE

1 complaint

CAR STALLS, DOESN'T PICK UP SPEED, HESITATES TO START, ENGINE LIGHT IS ON BECAUSE THE GAS VALVE NEEDS TO BE REPLACED. GAS WARNING COMES ON WHEN HALF FULL. GAS SMELL THROUGHOUT CAR. HAS A LOAD HUMMING SOUND WHEN DRIVING OR IDLED. JUMPS WHEN ACCELERATE. I HAVE TAKEN MY CAR TO A DEALERSHIP IN SAINT LOUIS (RELOCATED RECENTLY) AND THEY WON'T TOUCH IT.

Jul 23, 2019

VEHICLE SPEED CONTROL,ENGINE

1 complaint

MY CAR STALLS WHEN I COME TO A RED LIGHT ..ITS LIKE IT DONT WANA MOVE..SLOW ACCLER ATION

Jul 16, 2019

VEHICLE SPEED CONTROL,UNKNOWN OR OTHER

1 complaint

WHEN I STEP ON THE GAS, THE CAR SPORADICALLY WILL NOT GO. SO I WILL STEP ON THE GAS LITTLE BIT MORE AND THE CAR WILL STILL NOT GO. SO I WILL STEP ON THE GAS A LITTLE MORE AND THEN SOMETHING WILL ENGAGE AND I WILL SHOOT FORWARD. THIS HAPPENS IN PLACES WHERE IT COULD BE CATASTROPHIC. FOR EXAMPLE, ONCE I WAS AT A STOP SIGN AND THIS WAS HAPPENING AND BECAUSE MY CAR WASN'T MOVING, ANOTHER CAR STARTED TO GO AND MY CAR FINALLY ENGAGED AND SHOT FORWARD AND I NARROWLY MISSED HITTING THAT OTHER VEHICLE

Jul 16, 2019

ELECTRICAL SYSTEM,AIR BAGS,WHEELS

1 complaint

MY AIRBAG LIGHT KEEPS COMING ON. ALSO TIRE LOW LIGHT IS COMING ON I ALSO HEAR A BANGING NOISE WHEN I USE THE HEAT OR AIR., THIS HAPPENS WHETHER DRIVING OR PARKED.

Feb 06, 2019

STEERING,SUSPENSION,POWER TRAIN

1 complaint

TRANSMJTIONS FEELS SLUGISH ONE DAY NORMAL NEXT REVS UP AT TIMES MORE THAN NORMAL MAKEING VEHILCE SPEED UP WHEN NEEDING TO SLOW DOWN . SUSPENSION OFTEN WARPS OUT OF PLACE MAKEING THE DRIVE HARSH ON MOTAR AND FALLS BACK ON PLACE. STEEDING COLLUM FALLS OUT OF PLACE TO ODFTEN HAVE TO BEND THE WHEEL TO GET BACK ALIGNMENT

Apr 09, 2018

Crash: 1

VEHICLE SPEED CONTROL

1 complaint

TL* THE CONTACT OWNS A 2016 FORD FIESTA. WHILE DRIVING APPROXIMATELY 5 MPH, THE VEHICLE ACCELERATED SPONTANEOUSLY AND STRUCK A TREE. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS NOT DIAGNOSED BY THE DEALER. THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 5,000.

Nov 02, 2017

Crash: 1

STEERING,POWER TRAIN,SEAT BELTS

1 complaint

TL* THE CONTACT OWNS A 2016 FORD FIESTA. WHILE ATTEMPTING TO ACCELERATE, THE VEHICLE HESITATED AND FAILED TO ACCELERATE PROPERLY. IN ADDITION, A SCRAPPING TYPE NOISE WAS PRESENT COMING FROM THE STEERING WHEEL WHILE OPERATING THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEAL HAMILTON FORD DEALER LOCATED IN CLOVIS, NEW MEXICO, BUT THE FAILURE WAS UNABLE TO BE DUPLICATED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 8,000. ...UPDATED 10/19/17 *BF THE CONSUMER STATED THE SEATBELTS IN BACK WOULD LOCK UP WHILE IN USE. *JS

Aug 07, 2017

ELECTRICAL SYSTEM,EXTERIOR LIGHTING

1 complaint

DAYLIGHT RUNNING LAMPS INOPERATIVE AT TIME OF PURCHASE. PAID FOR TX INSPECTION. DISCOVERED AFTER LEAVING DEALERSHIP.

Aug 02, 2016

2016 FORD Fiesta Problems & Complaints

Complaints by Component

Frequently Asked Questions

How many problems does the 2016 FORD Fiesta have?

What are the most common problems with 2016 FORD Fiesta?

Where does this 2016 FORD Fiesta problem data come from?

Other Years - FORD Fiesta

Other FORD Models

Similar Brands