2022 FORD Mustang Mach-E Problems & Complaints
Real owner complaints and problems reported to the National Highway Traffic Safety Administration (NHTSA). View common issues by component.
VIN Decoder
115
Complaints Reported
As an Amazon Associate, ForCar.org earns from qualifying purchases.
Complaints by Component
ELECTRICAL SYSTEM
21 complaints
The contact owns a 2022 Ford Mustang Mach-E. The contact stated that while driving at an undisclosed speed, several unknown warning lights illuminated. The messages "Stop Safely Now", "Service Advancetrac", "Overdrive Off", and "Pre-Collision Indicator Off" were displayed. The contact pulled over and parked the vehicle. The vehicle failed to restart, and the 12-volt battery was drained. The vehicle was towed to the residence. The vehicle was later towed to the dealer, who determined that the high-voltage battery contactor needed to be replaced. The dealer performed the recall repair under NHTSA Campaign Number: 22V412000 (Electrical System); however, the failure persisted. The vehicle was not repaired and remained with the dealer. The manufacturer was made aware of the failure, and two cases were filed. The failure mileage was 104,442.
Sep 30, 2025
My wife was driving on the parkway when her Mustang Mach-E started flashing multiple warning messages on the HUD. The vehicle suddenly died with no power. She was in a center lane of traffic in a 6-lane section. The vehicle did not let her put the car into neutral to push it out of the way. When they tried to get back into the car they found that it would not open and after she and the police officer who stopped searched Google and YouTube, they learned that there is no way to manually open the vehicle with no power. This was confirmed by the dealership.
Sep 02, 2025
The recall has no estimated repair date: the initial notification was June 16th. This has passed a reasonable amount of time, with no repair but a "we think we might fix it around the 3rd quarter of 2025" - definitely not satisfying the law. Tesla already had one death from entrapment post accident: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Aug 04, 2025
My 2022 Ford Mustang Mach-E has experienced a complete failure of the front passenger door latch. The electronic latch (e-latch) button does not light up or respond, and the door remains fully open and cannot be latched or secured. This occurred without any damage or external cause. I’ve been informed that this issue requires full latch replacement at my expense, totaling over $760. I’m also aware of a pending recall (25S65) related to 12V discharge and door latch functionality, but I’ve been told my vehicle is not currently covered — even though the symptoms appear directly related. This is a safety-critical failure because the door cannot be secured while driving, creating a serious risk of passenger ejection in motion. This issue appears to be common among early Mach-E models and should be formally investigated.
Jun 18, 2025
The contact owns a 2022 Ford Mustang Mach E. The contact received notification of NHTSA Campaign Number: 25V404000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted and advised the contact that the part to do the recall might be available by the end of 2025. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Jun 18, 2025
+ 16 more complaints for this component
UNKNOWN OR OTHER
10 complaints
I brought my car to ford stanford for recall work and they didnt do it. Tried to charge me first even thought it was under warranty. Battery recall
Dec 29, 2025
Door Fault error Front Passenger Door will intermittently open on its own.
Jul 05, 2024
On 1/6/24 it just started lightly snowing and I drove the car home and parked in my diveway which has a slight incline. There was less than 1” of new light snow on my driveway. The car does not fit in the garage so I need to park it outside in order to reach the charger which is in the garage. I parked the car with the car in park and the emergency brake on and the car was off. I turned to go inside to open the garage so I could plug it in. My car started flashing and beeping and proceeded to roll down my driveway and into the road. a notification came up on my app stating that it was an “inclination alarm”. I couldn’t believe it so I then parked the car behind my other car in the driveway further down the driveway and the same thing happened. I then called my friend and he stayed with me on the phone while I stayed in the car to see if it would do it again and it did. The car litereally rolled down my driveway 3 times and I caught it on my security camera 2 times as the 3rd time the camera timed out. Yes, the car rolling into the road could literally kill someone and there are many children and pedestrians who walk in my neighborhood. . I took it to the local dealer on Monday when they opened and showed the video to the service manager and he was dumbstruck. The car ended up being there for almost 2 months while I filed a case with Ford. They had a regional technician check it out and they could not recreate the issue. They said that there is nothing mechanically wrong with the vehicle. They made me pick up the car or they would start charging me storage. They essentially said that it was just a condition of the car because it was heavy. No other car I own has ever done that. I travel locally for my business to people’s homes which is the reason I purchased this car. I cannot drive it during the winter months because it will roll away. Ford will not accept liabilty for it nor will they buy it back. I can’t attach the videos but I can email them.
May 02, 2024
1. Received recall 23S56/23V687 dated 10-13-2023. Initially no remedy available (lack of parts) 2. Early January 2024 recall updated to remedy available with note to schedule service with your advisor. 3. Called Mullinax Ford in Apopka Florida second week in January and clearly stated I was calling to schedule an appointment for HVBJB recall, noted above. Appointment was made for next available which was February 12, 2024. 4. February 12, 2012 I take vehicle to Mullinax Ford for 7:30am appointment. Advisor writes up HVBJB issues along with tire rotation and another software update for stuck charging plug. 5. Throughout the 6 hours of waiting at the dealer the service advisor neither updates me or informs me that the HVBJB recall is not taking place. They apparently performed another recall for a parking break release cable that was neither listed on the ford site or NHTSA as a recall applicable to my vehicle. 6. At the end of the 6hours they hand back my vehicle without the HVBJB recall performed and could not tell me when it could be performed or if parts were available or if they had even checked for the parts. They simply said they would get back in touch. I left to mull things over and clear my head. 7. Called back Mullinax Ford from the car and talked to someone named Michael after asking for the service manager. Explained I specially made the appointment a month ago for the HVBJB recall and that didn't happen and I wanted to know when they could have the part on hand and when I could schedule the recall. He said he would research it and call me back. 8. As of [XXX], three days later, I have not received an update. 9. The recall status now shows remedy unavailable again which means the part is obviously on back order. 10. This HVBJB problem surfaced in early 2022. The first recall which consisted of a software update in was issued in June 2022. There is no excuse for not having ample parts to remedy this in 2024. No long distance/fast charge driving. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Feb 15, 2024
There is a common software bug on Mustang Mach-E vehicles where the "drive mode" of the vehicle (a software feature that changes the braking, suspension, and acceleration characteristics of the vehicle) will suddenly change and a popup will appear on the screen stating "Drive Mode Unavailable" While decelerating to stop at a light, the "drive mode unavailable" warning appeared, the braking characteristics of the vehicle changed, and I ran out into the middle of the intersection.
Dec 08, 2023
+ 5 more complaints for this component
FORWARD COLLISION AVOIDANCE
6 complaints
The front camera has failed. The automatic emergency breaking, the adaptive cruise control, and normal cruise control do not work, at all. The camera began to fail within the first year of ownership but it would start to work shortly after. After about 1.5 years of ownership, there was a permanent sign of malfunction on the screen, making the above features inoperable.
Sep 02, 2025
The Adaptive Cruise Control indicated speed lags when user changes speed. The lag will fluctuate from non-existent to 4-5sec at times. It occurs at different speeds and for different changes (e.g., speeding up to 45mph or speeding down to 25mph.) It also occurs when changing speeds in different increments (e.g., one click up for 1mph increase or hold down for 5mph decrease.) The lag is only in the display and not the actual drivetrain, meaning that the selected speed in the Adaptive Control indicator is not relaying the selected speed even though the car itself is changing speed. This is a safety issue as you don't know whether the car has registered a speed increase or decrease for several seconds (which at higher speeds is certainly not safe.) There was an OTA related to the Instrument Control Panel sent earlier this summer that was successfully installed, IPC-25.7.46, however this may be a coincidence. After calling multiple times to Ford, including their OTA update team, their EV Technology Team, and a generic Customer Experience team, I was told to bring it into a dealership AND submit a complaint to NHTSA. The dealership identified modules that required updating but that did not fix the issue. Ford has NOT been helpful and their Customer Experience reps have been dismissive of the seriousness of this issue.
Aug 17, 2025
Multiple safety features rendered INOPERABLE AND USELESS including front collision warning, automatic emergency braking, adaptive cruise control, lane keeping system because FORD uses an inferior product to connect the vehicle's cameras and sensors. Each of the systems listed "front collision warning, automatic emergency braking, adaptive cruise control, lane keeping system" are now DISABLED and they are integral to preventing collisions. The vehicle is marketed with those features and is presumably justification of the MSRP charged to customers. FORD is apparently aware of the issue based on FORD forums, that replacement of windshield can comprise the coax cable. The company is using an outdated and less reliable coax cable to run sensors and cameras for an Electric Vehicle when a much more viable, pliable and reliable Fiber media has been available for over 20 years is shortsighted and cheap. Coax to run safety features also brings into question how that feature was safety tested. The vehicle was diagnosed by a Ford Dealership in PA, "U2107" code indicating an issue with the coax cable used to connect the sensors and camera. No component been inspected by the manufacturer, police, insurance representatives or others. Even though there were warning messages it is UNKOWN when the issue actually started or know exactly when the systems failed. I am sure FORD can check the messages store in the software.
Aug 12, 2024
The contact owns a 2022 Ford Mustang Mach E. The contact stated while driving at an undisclosed speed with the Adaptive Cruise Control activated, the steering wheel jerked in the direction of oncoming traffic. The contact depressed the brake pedal and steered the vehicle back into the correct lane. The contact stated that the “Driver Assist Not Available” message was displayed. The contact stated that the message was displayed after the vehicle jerked and steered into the oncoming traffic. The contact stated that the failure had been reoccurring for approximately one year. The vehicle was taken to the dealer. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 500.
Nov 28, 2023
Vehicle adaptive cruise control was set at 35mph in a 35mph speed zone as I approached a stop light I tapped the breaks which should have disengaged the cruise control but instead the vehicle speed accelerated. Warning light stated cruise control was disengaged with gray line through speed indicator. I stepped on the brakes hard and the vehicle did stop and accelerator stopped. At no time was my foot on the accelerator pedal as well floor mats were not touching the pedal. Outside vehicle was clean and camera unobstructed. This just started after update 4.2.5.
Jul 21, 2023
+ 1 more complaint for this component
SERVICE BRAKES
5 complaints
Vehicle: 2022 Ford Mustang Mach-E Mileage at failure: ~36,800 miles Complaint Description: The left rear electronic parking brake (EPB) wiring harness/connector failed, resulting in a parking brake fault and abnormal braking behavior. This component is not a wear-and-tear item and is located in a fixed, protected area of the vehicle. It is not subject to routine maintenance or driver interaction. The failed wiring harness was inspected by an authorized Ford dealership and is available for further inspection upon request. This failure put safety at risk because the electronic parking brake is a safety-critical braking system. The fault created uncertainty regarding proper engagement and release of the parking brake, increasing the risk of unintended vehicle movement when parked and reduced confidence in braking reliability while driving. The problem was confirmed and diagnosed by a Ford dealership, which determined the wiring failure developed over time due to moisture intrusion and corrosion, not misuse, accident damage, or normal wear. The vehicle and component were inspected by an authorized Ford dealership. Ford Motor Company reviewed the repair documentation through Ford Customer Care but did not dispute the diagnosis. The component has not been inspected by police or insurance representatives. A parking brake fault warning message appeared shortly before diagnosis, accompanied by abnormal braking behavior. There were no prior accidents, vehicle modifications, or external damage related to the failure. This failure is identical to a known defect already acknowledged by Ford in Customer Satisfaction Program 22P31, which covers EPB wiring harness connector failures on other 2021–2022 Mustang Mach-E vehicles. Although my VIN was excluded, the same non-wear safety defect occurred within the same model year, indicating a broader safety concern beyond the original VIN population.
Jan 16, 2026
After 22,207 mi, the right rear wheel unit started making a clunking similar to a flat tire. I looked online and found TSB 22-2023 which states that a common problem with the Mach E one pedal driving is brake pad material gets fused to the rotor. I took it in for repair and the brakes are out of warranty after 18000mi. Average life of brake rotors FOR CARS THAT USE THEIR BRAKES is 30,000-70,000mi. If Ford knowingly continues to use brake components that become faulty and fail after such.a short time on cars that don’t regularly use brakes, this problem could cause serious brake failure in cases of emergent braking. One pedal users would not know their brake pads had fused to the rotors until too late and the braking system fails when they need it.
Feb 22, 2025
The vehicle was delivered [XXX], its an EV and does probably 70% highway/30% city driving. As an EV is on "one pedal" mode exclusively to use the motor to brake the vehicle and regenerate charge to the battery so we rarely use the actual brakes. at 18k mile we notices when the brakes were applied the vehicle and steering wheel shock, we took the car in for service and the front brake rotors were re-surfaced as per Metro Ford in Miami, FL. We noticed again at 22k miles and then Metro Ford in Miami, FL replaced the front rotors as they could not be resurfaced since they were already resurfaces once and would have been out of spec. At 28k miles we notices again, we took it again to Metro Ford in Miami, FL and they said it was cause by brake pad glazing and pad needed to re-surfaced and this time also resourced the rear rotors. All this is been done under warrantee with the exception of replacement of front pads in the last repair as Metro Ford in Miami, FL considered them a "wear" item (even with clear history with brakes) the approximate cost was $427. I believe there is clearly a brake defect with my car as i dont see how an EV on one pedal driving has needed to have front rotors resurfaced 2x and replaced 1x, needed new front pads, and need rear pads resurfaced 1x in less then 2 years/28K miles. Summary of brake repairs - 18k Miles - front rotors re-surfaced - 22k miles - front rotors replaced - 28k miles - front and rear rotors re-surfaced / front pads replaced INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Apr 22, 2024
I just had a similar experience about four hours ago during normal conditions (dry and daylight). I was approaching a red light that controlled an on/off ramp intersection where a rural road intersects a state Highway. I was on the rural road. As I started braking, the pedal almost immediately felt soft. I kept pressing (never pumped) the brake pedal steadily lexpecting to feel more normal resistance. The brake pedal traveled more than double the distance that it normally does. I started to get some braking, but I don’t think I could have locked up the brakes if I wanted to. The emergency braking didn’t engage; however, there wasn’t a car traveling in my lane between me and the intersection. There were cars exiting the freeway and turning through the intersection immediately in front of me. Fortunately, I had enough brakes to stop just before the intersection. I had my wife and son in the car. I will be having the local Ford dealership look over the car. That incident happened 5-10 minutes after leaving my house. I had used my brakes during this trip prior to the incident. The brakes worked normally for the remainder of the 20 minute trip. Whatever is going on, isn’t right and although I never was dangerously close to an accident, if conditions were slightly different it could have been very bad.
Mar 15, 2024
Brakes automatically engage when parked. Next time I went to drive the car wouldn't move until a loud "clunk" came from the rear and the car moved. But, when I started driving there was a repetitive noise coming with each turn of a rear wheel. Parked the car and took to dealership which confirmed that a "chunk" of the brake pad had come off and adhered to the brake rotor. Contacted Ford and was told that it wasn't covered under warranty because I had gone more than 12, 000 miles. They did set up a case (CAS-46526025-Q7S5V2), but I never heard anything from it. In conversation with the dealer, this is apparently a common problem for which Ford has issued at least 2 TSBs (21-2206 & 22-2023) but the term expired before my incident. From reading of other incidents on various forums for the MachE, it is apparent that the problem still persists as in my case and is affecting a number of owners. Ford needs to be pressured into issuing a recall to install improved brake pads/rotors to prevent this problem from occurring. It could happen at a time when it isn't easy to pull over and therefore, cause an accident.
Dec 19, 2023
VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE
5 complaints
Shortly after purchasing my vehicle on [XXX], specifically on [XXX] a significant malfunction was encountered, indicated by the 'Front Camera Fault Service Required' and 'Pre-Collision Assist Not Available' warnings. Returning to the dealership on May 5th, the manager misinformed, stating the issue was a recall and required service at a Ford dealership. However, upon contacting Ford Lincoln with the VIN, it was discovered these codes are not associated with any recall. I returned to the dealership, provided them the printout from Ford Lincoln explaining the codes and how it's not a recall. They then told me that they will not honor the repairs due to me exceeding my 30-day extension. I proceeded to leave and said I'll deal with it when it poses a problem. After a resent software update, a new code popped up saying "Door Fault Service Required". July 2025 Koons Ford picked my car up and they confirmed that the issues documented in the attached photos are not covered by any recalls. However, this experience is further corroborated by attached photos and testimony from others reporting identical recurring problems since 2022. You can reference to the [XXX] " for the other vehicle owner's testimony. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Aug 08, 2025
On 3 occasions in the past month I have been driving down the road and, without any action from me, cruise control has turned itself on, with a speed set above the speed limit. I noticed it because the car accelerated to reach the target speed (which was an unsafe speed). I immediately braked and turned off the cruise control. The first two times it happened, I was pretty sure I had not accidentally activated cruise control by touching the button on the steering wheel. The third time, I was on a straight stretch of highway and was 100% sure I had done nothing to activate cruise control I had not used cruise control at any point from the time I turned on the car until the time this happened. I was between 10 and 15 minutes into my trip when this occurred.
Jun 30, 2023
On at least 8 occasions the car unintentionally shifted into cruise control and accelerated immediately. This usually happened while driving under 30 mph and rapidly accelerated to a much higher speed, sometimes set as high as 70 mph. On 3 occasions this happened in a parking lot and 2 occasions in a bank drive thru with a vehicle only a few feet in front of me. Immediate emergency braking was required to avoid an accident with two very close calls within 1-3 feet of vehicle in front of me. This experience has been reported by numerous persons on the Mach E Forum (similarly complaining of near accidents) and the general conclusion is that the button that activates cruise control is both unnecessarily super sensitive and poorly located so that it is engaged by the lightest touch of your left palm, base of your left thumb, or another finger as you move it across the steering wheel. Please note that the form below does not allow for numerous occurrences.
May 31, 2023
The cruise control is activated by the slightest touch of the button. Running the heel of your hand over the button will activate it. The button acts like a screen touch rather than a button.
Apr 20, 2023
I am randomly receiving the errors: "Front Camera Fault" "Pre-Collision Assist Not Available" Also, my cruise control no longer works while this error is active. Error will clear itself after a few minutes, but will still pop up from time to time.
Jan 13, 2023
POWER TRAIN,ELECTRICAL SYSTEM
5 complaints
I was driving on the freeway when out of nowhere the vehicle alerted me to "Stop safely now". I no longer had any power and could not accelerate. I was doing 70 MPG in the middle lane and had to switch to the right lane, then to the shoulder of a busy interstate. This was extremely dangerous as I was losing speed quickly, and luckily had no one to my right side. If there was traffic I would have been at risk with anyone to my right also at risk. Once I was on the shoulder I tried to restart the vehicle with no success, eventually it just completely lost all power. This vehicle is full electric and had 76% charge at the time of the incident with 23,642 miles. I am very dissatisfied with how unreliable this vehicle was by just turning off in the middle of the road. The worst part was Ford roadside assistance took over 5 hours to get the vehicle towed to the dealership. I was stranded on the side of the freeway, completely unacceptable.
Aug 11, 2024
After plugging my Mach-E into a Blink Charger at Sheehy Ford in Ashland, VA my vehicle became disabled and will not go into propulsion mode. The car is now 98% charged but will not come out of Park. The dealership blames a NHTSA stop work order on a software update that in their words would resolve the issue.
Jul 11, 2024
I have a 2022 Mustang Mach E GT Performance edition. I purchased it new and am the first owner. The build date is September 2022 and I received a notification in the Ford Pass Mobile phone application saying: - High Voltage Battery Warning - Powertrain Malfunction / Reduced Power This is a known issue for build dates before May 2022, so my car should've not been affected, but it is. I've scheduled a service appointment for further diagnostics with the authorized service center where I purchased the car.
Nov 06, 2023
This is the second time in 2 months that I’ve received a High Voltage Warning and Powertrain fault on my MME ‘22. This was suppose to have been fixed by a recall completed prior to my build date. I have been driving normal speeds on side streets when this happens.
Oct 08, 2023
faulty high voltage battery junction box NHTSA Campaign Number: 22V412000
Oct 13, 2022
ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM
5 complaints
Car suddenly lost all power and flashed multiple warnings. Steering also became disabled. This was moving at a low speed through a school zone so it did not cause an accident. After several restart attempts the car moved again but quickly same issue occurred. Car was towed to Ford. Still waiting for diagnostic.
Apr 11, 2024
Car got a stop safely now error and stopped working. I had to call a tow truck and have it sent to a dealership.
Dec 17, 2023
I bought a 2022 mustang Mach e. Which was supposedly fixed at the factory in regards to the HVBJB issue. However, in mid 2023, my vehicle suffered a limp mode/warning about reduced power while on the interstate, was limited to about 60mph with very poor acceleration. Was diagnosed by ford tech as a failure of the recalled part and required HVBJB and BECM replacement, similar to 22V-412 recall. I think this should be added to RQ23004 investigation, as these vehicles had both the new hardware and software and were supposed to be “fixed”.
Aug 21, 2023
The HVBJB subassembly in ALL Ford Mach-e vehicles has known defects with 'under-designed' main contactors that are known to fail under normal charging and driving conditions as outlined in current open Ford recall notice for my vehicle 22s41. Unfortunately, the internal damage to contactors is not visible externally, and warning notices on display only after damage has occurred, and can result in sudden loss of propulsion power at highway speed, loss of power steering, and power brakes... and failure of other 12v systems due to failure to charge the 12v battery properly after contactors are damaged. Less catastrophic results can include failure to start; which can 'strand' driver's and passengers in remote areas, bad weather conditions, as well as cause loss of use for weeks due to delays in replacement parts and local Dealerships needing equipment and training to effect removal/replacement of faulty unit with a new HVBJB having re-designed 'beefier' components. My complaint is that Ford's recall notice 22s41 is a software-only attempt to prevent future damage, and does not require removal of the part(s) which are KNOWN TO FAIL to be replaced with the re-designed components which are available, and have been used to repair failures under warranty. I have no way of inspecting the original equipment to evaluate current condition; and failure can result in sudden and unexpected loss of power, steering, and braking as well as potentially 'stranding me' in unsafe conditions unable to re-start my vehicle. I would like to see NHTSA strengthen the Ford recall to include both improved software AND removal/replacement of the HVBJB sub-assembly with the new 'beefier' parts.
Oct 10, 2022
The High Voltage Battery Junction Box (HVBJB) in ALL Ford Mustang Mach-E vehicles has known defects with faulty main contactors that are known to fail under normal charging and driving conditions as outlined in current open Ford recall notice for my vehicle 22S41. Unfortunately, the internal damage to contactors is not visible externally, and warning notices on display only after damage has occurred, and can result in sudden loss of propulsion power at highway speed, loss of power steering, and power brakes...and failure of other 12v systems due to failure to charge the 12v battery properly after contactors are damaged. Less catastrophic results can include failure to start; which can strand driver's and passengers in remote areas, bad weather conditions, as well as cause loss of use for weeks due to delays in replacement parts and local Dealerships needing equipment and training to effect removal/replacement of faulty High Voltage Battery Junction Box (HVBJB) with a new one. ? My complaint is that Ford's recall notice 22S41 is a software-only attempt to prevent future damage, and does not require removal of the part(s) which are known to fail to be replaced with the re-designed components which are available, and have been used to repair failures under warranty. I have no way of inspecting the original equipment to evaluate current condition; and failure can result in sudden and unexpected loss of power, steering, and braking as well as potentially stranding me in unsafe conditions unable to re-start my vehicle.? ? I would like to see NHTSA strengthen the Ford recall to include both improved software AND removal/replacement of the High Voltage Battery Junction Box (HVBJB) with a new one.
Jul 11, 2022
ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM
4 complaints
Ford knowingly sold unsafe vehicles. NHTSA caught them and forced a recall on the High Voltage Junction Box (they are still failing, so you may want to look into this). But what they have hidden from you and all of it's customers that they suckered in buying their defective product, is that the front motors, have undersized wiring, which could cause a fire . They have attempted to hide this from the public, by limiting the power of the car to 5 seconds of full power and then dramatically decreases the power after that. The sold the cars to consumers without revealing that fact, so folks bought the performance "GT" versions and yet they are neutered. It's only a matter of time, where those tiny wires in the front motors give up and start causing fires. It's time for the government to stand up for he consumer here. I've brought it to [XXX] 's attention, but they are hoping we all go away and allow them to get away with selling a defective potentially dangerous vehicle INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Oct 24, 2024
- What component or system failed or malfunctioned, and is it available for inspection upon request? According to Ford Service, this is confirmed to be a High Voltage Battery Junction Box failure (HVBJB). The part is pending replacement currently at Central Ford, CA. While Ford issue recall (23S56) to replace all HVBJBs in Extended Range and GT model '21 and '22 vehicles built before May 24, 2022, my car was built after the date. - How was your safety or the safety of others put at risk? The failure of HVBJB directly leads to the lose of power suddenly when driving on the highway. I was cruising on california state highway CA-110 while the car pops up "stop safely now" on the instrument cluster. I lost all power for acceleration and relies purely on 12V battery to power the accesories. There was no emergency lane near the location of the incident which leads to the blockage of highway on the junction from CA-110S to I-10W. This post a significant threat to me as the driver and all other drivers on highway. More importantly, the 12V almost died before the tow truck and police could arrive to solve the incident. Fortunately, I was not hit by ongoing vehicles, but multiple vehicles have to brake agressively to prevent collision. The car was unable to be shifted to N or D since the incident. -Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle had been inspected by Service department at Central Ford and confirmed by engineers at Ford to be a HVBJB failure. - Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? 2 warnings and notifications can be seen from information cluster: "Full accessory power active", and "Stop safely now." There is no information displayed on the main infotainment screen.
Apr 25, 2024
After charging for the first time at a DC fast charge station to 80%, I resumed my trip and drove about 3 miles to merge onto the expressway, my screen panel said "safely stop now", with a turtle logo and battery icon coming on. my car then came to a complete stop within a few seconds in the middle of the on-ramp leaving me stranded. I repeatedly tried to turn the car on and off to see if i could get it to accelerate again but to no avail. I was stuck in the middle of the merge lane where my car would not move. After trying several attempts to rebooting, locking, turning off the car completely for 10-30 minutes, nothing worked. Although the accessory power said it was active there was no AC. After a couple of hours of waiting for a tow truck that would actually work with an EV, I locked the car again and tried to start. There were no warning lights so I tried to go to get off the expressway. After 3 miles at 70mph, the same warning lights came on and the car started to decelerate and then stopped. Luckily I was able to get over to the side of the interstate. After still waiting on tow truck for another 2 hours, lights inside the car started blinking, a loud banging sound started coming from the car and then nothing would work. Screens were black, doors were locked, windows wouldn’t roll up. No accessory power at all. It was 95° in Florida sun and I was completely stuck in the middle of nowhere at the mercy of any tow truck that would come help. It took 6 hours to get someone to come. He jumped the 12V battery and the car turned on and we loaded it onto the flatbed and took it to the dealership. Waiting now to see what is happening.
Jun 06, 2023
The HVBJB subassembly in ALL Ford Mach-e vehicles has known defects with under-designed main contactors that are known to fail under normal charging and driving conditions as outlined in current open Ford recall notice for my vehicle 22S41. Unfortunately, the internal damage to contactors is not visible externally, and warning notices on display only after damage has occurred, and can result in sudden loss of propulsion power at highway speed, loss of power steering, power brakes, and failure of other 12v systems due to failure to charge the 12v battery properly after contactors are damaged. Less catastrophic results can include failure to start; which can strand driver's and passengers in remote areas, bad weather conditions, as well as cause loss of use for weeks due to delays in replacement parts and local Dealerships needing equipment and training to effect removal/replacement of faulty unit with a new HVBJB having re-designed components capable of meeting safety and normal usage requirements of Mach E owners.? ? My complaint is that Ford's recall notice 22S41 is a software-only attempt to prevent future damage, and does not require removal of the part(s) which are KNOWN TO FAIL to be replaced with the re-designed components which are available, and have been used to repair failures under warranty. I have no way of inspecting the original equipment to evaluate current condition; and failure can result in sudden and unexpected loss of power, steering, and braking as well as potentially stranding me in unsafe conditions unable to re-start my vehicle.? ? I would like to see NHTSA require that the Ford recall include both improved software AND removal/replacement of the HVBJB sub-assembly with the new appropriately specified parts.? Failure examples: https://www.macheforum.com/site/threads/-post-battery-contactor-recall-first-junction-box-failure-.19209/ and https://www.macheforum.com/site/threads/post-recall-software-hvbjb-failure.19396/
Jul 07, 2022
VEHICLE SPEED CONTROL
3 complaints
I was backing up the car and the car raced on it own at least couple of times. Luckily no-one was injured. I am worried about the safety of my family including a newborn. There was a Recall 22S29 for the mach-e but it seems to have not fixed the issue for my car.
Jan 15, 2026
The contact owns a 2022 Ford Mustang Mach-E. The contact stated while reversing at slow speeds in a parking area, the vehicle suddenly independently accelerated. The contact briefly lost control of the vehicle and came to a complete stop after striking the curb. No warning lights were illuminated. The vehicle was towed to the dealer, who was unable to diagnose the vehicle or duplicate the failure. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 17,000.
Sep 11, 2024
Vehicle had an unintended acceleration resulting in crash in a parking lot.
Aug 17, 2022
ELECTRICAL SYSTEM,UNKNOWN OR OTHER
3 complaints
Passenger front door stopped opening from the outside. there is no power going to the door at all. There are alert codes appearing on the dashboard "passenger door ajar" "door fault. service required" I have taken it to Ford multiple times over the last 1 year, starting Dec 2024, for a fix and they are unable to find a solution. they attempted replacing physical parts with no success. There were no warning signs before this happened. One day i went to close my front passenger door and it would not open back up. This presented as a safety risk to me when I was being followed by a stranger, with my infant with me. I got in the car and pressed the lock button, but the stranger was still able to open my door. luckily I was able to drive away fast enough. however. because the door was seen as ajar, the car will not lock. this is a major safety issue when I cannot secure my vehicle to keep me and my child safe!
Nov 17, 2025
Suffered a “ stop safely now” error message. The battery warning light came on. Vehicle was parked at the time and suffered this error which wouldn’t let me start or shift into gear. I already had the HVJB replaced last year, September 2022.
Sep 10, 2023
To whom it may concern, Today I washed my car for the first time. My brand new Mach-E that I purchased 2 weeks ago. While going through the car wash the charging port opened up and got soaked with soap and water. This effects the vehicle charging capability and cause an electric issue to the car.
Sep 07, 2022
POWER TRAIN
3 complaints
I have a 2022 Mustang Mach-E GT and have now experienced two (2) High Voltage Battery Junction Box (HVJB) failures. First failure was in July 2023 when the vehicle had approximately 12,000 miles. I received the stop safely now message. Vehicle codes displayed via the Ford app showed a High Voltage Battery Warning and Power train Malfunction / Reduced Power warnings. I have now received this same failure and warnings again. The car currently has 54,000 miles and I was just advised by my dealer that the HVJB has failed a second time. My concern is that the replacement voltage boxes are nothing more than a Band-aid for the problem and not a permanent solution. As I prepare to receive by 3rd HVJB, I feel this is nothing more than a temporary fix until I receive another Stop Safely Now message while operating my vehicle. Please look into the HVJB failure rate for these vehicles. I am in online two Mustang Mach-E owners groups and this issue is rampant among owners. I feel this issue requires outside attention as Ford has now had 4 years to solve this issue for early produced Mach Es. Yet the issue continues to exist. Thank you for your attention in the matter.
Sep 16, 2025
The high voltage battery junction box has failed for the second time in 2500 miles. Car left me stranded in a Home Depot parking lot as it would no longer move.
Jun 26, 2024
The vehicle stopped moving in the middle of travel. There was no indicator or warning. The car was towed to a service center and diagnosed that the back motor of the car was broken. Ford did not have any updates nor fixing the problem.
Aug 02, 2023
ELECTRICAL SYSTEM,LATCHES/LOCKS/LINKAGES
3 complaints
The contact owns a 2022 Ford Mustang Mach-E. The contact received notification of NHTSA Campaign Number: 25V404000 (Electrical System, Latches/Locks/Linkages); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while attempting to exit the vehicle, the doors automatically locked independently. The contact called AAA o assist with unlocking the vehicle to be able to exit the vehicle. The dealer was contacted and confirmed that there was no fix yet available. The manufacturer was made aware of the failure and sent AAA to assist the contact. The failure mileage was unknown. VIN tool confirms parts not available.
Jul 22, 2025
The contact owns a 2022 Ford Mustang Mach-E. The contact stated that the rear driver's side door and passenger's side doors failed to open intermittently. The vehicle was taken to an unknown dealer, where the failure could not be duplicated. The contact later became aware that the VIN was included in NHTSA Campaign Number: 25V404000 (Electrical System, Latches/Locks/Linkages), which the contact related to the failure; however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and advised the contact that the VIN was not included in the recall; however, the VIN tool confirmed that the VIN was included in the recall. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 25,000. VIN tool confirms parts not available.
Jul 01, 2025
The contact owns a 2022 Ford Mustang Mach-E. The contact stated that, upon starting the vehicle, the screen above the steering wheel was producing errors. The door open and trunk open messages were displayed. The brake pedal was pumping without being depressed. The main screen was frozen and not operational. The driver turned off the vehicle, but upon restarting, the vehicle failed to shift into gear. The contact called the local dealer, who informed her about the access panel on the front bumper. The contact exited the vehicle and closed the driver's side front door; after opening the access panel, the contact attempted to jumpstart the vehicle, but the vehicle failed to start. The contact stated that the doors locked with her son and two dogs inside the vehicle. The window was down approximately three inches. The contact's child was inside the vehicle but was unable to unlock the doors from inside the vehicle due to the 12-volt battery being drained. The contact stated that the hood failed to open. The manufacturer was contacted, and referred the contact of Ford SYNC and informed the contact that the vehicle was flagged, and the 12-volt battery was low, and an update was needed, and directed her to Roadside Assistance. The contact called Roadside Assistance, who was unable to jump the vehicle with several jumping devices. The contact used a portable battery to access the vehicle. The vehicle began making an abnormal knocking noise and jerking. The Fire Department was on the scene and was able to assist. The contact pulled down the rear window, knocked the window off track, and was able to get into the vehicle. The contact was able to climb through the window, pump the brake pedal, open the door, open the hood, jumpstart, and charge the vehicle. The contact was able to drive the vehicle. The manufacturer was contacted again and opened a case. The contact provided feedback and was referred to the local dealer and to the NHTSA Hotline. The failure mileage was approximately 19,995.
Mar 14, 2024
POWER TRAIN,FUEL/PROPULSION SYSTEM
3 complaints
I was driving my car when all of a sudden it lost all acceleration and power, I was lucky that I wasn't on the highway anymore and was able to pull over safely on a side street while car was rolling still. Dealer said 12V battery fused, and I have been reading forums where this is a common issue.. In a normal ICE car when 12V battery dies while driving, car can still drive, in this case, it just stops and pops up a dozen errors about everything being broken.
Jul 08, 2025
Just towed to Ford dealer. When car was in Drive mode, would go in Reverse. I have video and posted it to the Ford Facebook page.
Jul 29, 2024
Powertrain malfunction warning while driving to work on 55MPH road. This has occurred twice since buying the car new. November 14, 2022 with 9k miles was when the first warning/malfunction occurred. HVBJB was replaced. This last/second powertrain malfunction and High-Voltage battery warning occurred on May 26, 2023 with 15k miles. HVBJB replaced again. This warning resulted in reduction of power, but not full loss of power. Unfortunately, the last time this occurred was when I was attempting to pass on a two lane road. The power reduction when this warning occurred prevented me from safely passing and getting back in to my lane. Image of warnings on my Ford app are attached for details and dates. Northfield Ford (Northfield, MN) replaced the HVBJB on both occurrences. I have never used a DC Fast Charger. Most used charger is 110v.
Aug 21, 2023
POWER TRAIN,ELECTRICAL SYSTEM,ENGINE
3 complaints
- What component or system failed or malfunctioned, and is it available for inspection upon request? According to the technician, there was a 12-volt battery in the beginning, but after staying in the shop for three days, they found that it was HVBJB, also known as the bussed electrical center (BEC). The car was recalled last July and was in the shop for about a month for HVBJB, also known as the bussed electrical center (BEC). The shop had already replaced the part last year. - How was your safety or the safety of others put at risk? The car suddenly stopped and lost battery power when I was driving on [XXX] going to [XXX]. Las Vegas, Nevada. The car turned off, and there was an error message on the screen. I could not move the car anymore. "When the car suddenly stopped, my wife and I felt like we had hit a wall at 45 miles per hour". - Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, last year, it was by Galpin Ford in Los Angeles when the vehicle was called for a recall in that specific part, and now it was by Gaudin Ford in Las Vegas when this incident happened and they claim they need to replace the same part. Recall Reference Number: 23S56 - Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes, last year, it was by Galpin Ford in Los Angeles when the vehicle was called for a recall in that specific part, and now it was by Gaudin Ford in Las Vegas when this incident happened and they claim they need to replace the same part. Recall Reference Number: 23S56 - Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mar 10, 2025
While driving, the car suddenly stopped, showed a "Stop Safely Now" warning and stopped in the middle of a busy road. Car went into Park and could not be moved from the middle of a busy road. Remained in Park and could not even be shifted into Neutral to be pushed out of the way of bust traffic. Very dangerous. No prior warning. Car had to be towed and now at deal for investigation into cause.
Dec 26, 2024
While driving on Route 1 and attempting to pass another motorist, a flashing red "STOP SAFELY NOW" lit on my dashboard, along with multiple warnings of a "powertrain failure". Thankfully I was near my house and was able to get home. But the FordPass App is saying that I had a high-voltage power malfunction and will need to tow the car to my local dealership. Now I am being told that the high-voltage junction box has failed and needs to be replaced (consistent with Ford Recall notice 23S56). Unfortunately, Ford hasn't produced a replacement part, and after speaking with multiple dealerships, I have been told that an updated replacement part may not be available until Q1 2024 (Or between 6-18 weeks from now). Those of us who purchased these vehicles now have $65K+ paperweights. Ford should buy back these cars, fix them, then resell them through local dealerships. Please help remedy this situation.
Nov 23, 2023
STRUCTURE
2 complaints
Glass roof was cracked in December by what looked like a shell dropped on the top. Had it repaired by insurance on January 16, 2025. Less than two months later, there is another crack that appeared out of no where. Was not at work that week and the car was parked in my garage. I never felt any impact of any kind. Sent pics to insurance (sunroof express) and they are refusing to cover it under warranty.
Apr 09, 2025
While driving a warning message in red was displayed on the driver display indicating that the frunk(front trunk) hood was open and that the emergency frunk release had been activated. I pulled over and stopped and got out and closed the frunk hood. I continued driving and upon braking, the messages appeared again. This time I opened the hood and discovered that a folded hard-sided bag that was in the frunk had slid up against the emergency release button with enough force to trigger the emergency release.
Sep 08, 2022
POWER TRAIN,ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM
2 complaints
On November 18, 2022 my vehicle's High Voltage Battery Junction Box (HVBJB) failed. Ford replaced this part with an "upgraded" version of this part and I received my car back on November 28th. Shortly thereafter, the NHTSA issued a recall, the solution for which was a software update that my car received. On October 10, 2023 my vehicle's HVBJB failed once again (the newer upgraded part). Coincidentally, while my car was in the shop, the NHTSA issued a second recall for this issue, indicating that Ford would be recalling the physical HVBJB. Shortly after this recall, my recall was marked as complete because I received the upgraded version of the part once again. Ford's upgraded part that is a solution to this issue has been issued in many Mach-e cars and is the standard for late '22 models and '23 models; however, in addition to my own HVBJB failing, I am hearing many instances of this newer part failing. Being that this recall stemmed from vehicles potentially losing propulsion as a result of this failure, the risk still exists (although potentially at a lower rate). I do, however, believe that Ford knows that this failure rate is still high and that their upgraded part does not provide a sufficient solution to the problem but has not been transparent with the NHTSA due to the costs associated with redesigning a third version of this part. I do not feel safe driving my family in this car because I know that it's just a matter of time before this part fails once again.
Nov 06, 2023
The high voltage battery junction box failed on my car at 9500 miles, and now again at 19200 miles. Failure prevents the car from running properly, or at all. The dealership is reporting that Ford has not developed an updated replacement part, and is only replacing with the same part that the vehicle left the factory with.
Sep 28, 2023
SUSPENSION
2 complaints
The stock suspension is dangerously defective. Both front and rear suspension do zero dampening and rebound necessary to keep the vehicle tires in contact with the road. When driving 50 to 70miles an hour on the highway, whenever I encountered a regular dip on an overpass, the front and rear wheels go slightly airborne. On several occasions driving on I-69 in Houston area, at one of the curved overpasses near Hilcroft Rd, slightly rainy wet and slick highway road, at 55 mph, my Mach E went airborne for a split second after passing thru one of the normal dips or seams on the concrete highways. I felt the vehicle was out of control going airborne for a split second and then regaining control after the up and down bounce subsided. I complained to my dealer (Helfman Ford). Their response was... they couldn't do much about the suspension because there were no recalls nor TSBs. However, they were able to log the complaint directly to Ford. I don't know the exact date of occurence, but one of the instances was sometime in the month of April 2023.
Aug 14, 2023
Nothing has failed, but I've determined the Suspension in all Ford Mustang Mach-Es from 2021-2023, excluding the Mach-E GT Performance is flawed. At first I thought it was just unengineered and terrible, but i've come to the conclusion that it's possibly dangerous. Driving yesterday on a city street and the road had a slight transition from left to right and at that very place , the road also has a bit of a bump, i hit that during the slight transition to the right and the car bounced up and the rear end almost stepped out, putting the car sideways (It did not, but slightly faster or more of an angle change, it's very possible it would have). Again as I stated before, the suspension is underdamped for the weight of the vehicle and it's quite easy for it to get unsettled, heck even just coming out of a parking lot it can get unsettled. I'm afraid someone is going to find this out the hard way and someone is going to get hurt. I'd say this is akin to loading a 1/2 ton truck with 1 ton of cargo, it is illegal and really this suspension trying to handle the battery weight, plus the car and passengers, it's just not up to the task. As a Ford shareholder, it's not that I'd like to see Ford hurt. I'd like to see them fix this issue and actually engineer a safe suspension,a capable suspension for a vehicle that almost weighs 5K lbs.
Apr 18, 2023
ELECTRICAL SYSTEM,UNKNOWN OR OTHER,SERVICE BRAKES
1 complaint
On Tuesday, [XXX], between approximately [XXX] and [XXX] PM EST, I parked my Mustang Mach-E, powered the vehicle off, and exited the car with my wife and child. After unloading groceries and sports equipment, I retrieved the Level 2 charger from the front of my garage and plugged it into the vehicle. I waited for the blue indicator lights to turn solid and blink, confirming charging had started, which typically takes about one minute. I believe the vehicle had been parked and powered off for approximately 10 minutes when I entered the house. Shortly thereafter, I heard an unusual clicking noise and observed the charging cable strike the side of the garage door opening. The vehicle had rolled backward approximately six feet, twisting and pulling the Level 2 charging unit off the joist it was mounted to and damaging the vehicle’s front charging port as the cable stopped the vehicle from rolling into the street. This incident occurred less than one week after the vehicle was returned from service for a “Parking Brake Fault – Service Now” error that was repaired at Losco Ford in Fenton, Michigan. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Jan 08, 2026
STEERING
1 complaint
On November 15, 2024, my Ford Mustang Mach-E was involved in a rear-end collision on Interstate 270 near Clarksburg, Maryland. I was struck at high speed by a box truck, which pushed my vehicle forward into the van in front of me. The rear of the vehicle sustained significant damage, including the complete shattering of the rear window. During the impact, the steering wheel detached from the steering column and came off entirely in my hands. This occurred without the airbag deploying in the steering wheel area. The separation exposed the internal column components and wiring. This type of failure appears to be a serious safety defect. A steering wheel should not detach from the column in a rear-impact collision, and the separation could have resulted in loss of control or severe injury. I am submitting this report because I believe this warrants investigation for potential structural or component failure in the steering column assembly. I have photographs documenting the rear damage, the detached steering wheel, and the exposed steering column.
Dec 04, 2025
VEHICLE SPEED CONTROL,UNKNOWN OR OTHER,SERVICE BRAKES
1 complaint
I was waiting in a drive thru behind a line of cars at a full stop for some time, so I was using One Pedal assist/Auto Hold. My car suddenly accelerated and slammed into the car in front of me.
Aug 11, 2025
ELECTRICAL SYSTEM,AIR BAGS,SERVICE BRAKES
1 complaint
Vehicle Information: •Make: Ford •Model: Mach-E •Model Year: 2022 •Vehicle Type: Electric SUV •VIN: [XXX] •Mileage at time of incident: 31114 •Purchased in: California Incident Date: [XXX] Location: Laguna Niguel, CA Injury: Yes Crash: Yes Fire: No Airbags Deployed: No Police Report Filed: Yes Description of Complaint: On or around [XXX], I was driving my 2022 Ford Mach-E when the steering wheel suddenly locked and the braking system failed completely. I lost all control of the vehicle and was unable to slow or steer the car, leading to a crash. Despite the severity of the incident, the airbags did not deploy. At the time, I did not have obvious injuries, but shortly afterward, I began to experience severe pain and physical impairment, including an inability to stand or walk without difficulty. These symptoms have worsened and are now impacting my daily life. The vehicle is now completely inoperable and appears to have suffered a critical system malfunction, possibly involving its electric or software control systems. There were no warning lights or indicators before the failure. I believe this is a serious safety defect in the Ford Mach-E and could pose a danger to other drivers. I am requesting that the NHTSA investigate whether this is part of a broader pattern of defects affecting Ford’s EV line and take action to prevent further injuries or fatalities. Contact Information: •Name: [XXX] •Phone: [XXX] •Email: [XXX] •Preferred contact method: email INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Jul 03, 2025
ELECTRICAL SYSTEM,SERVICE BRAKES
1 complaint
I was driving my car like normal when a handful of warning signs popped up on the front screen and the brakes went out. I could only stop by pushing on the pedal with all my force, and it eventually slowed the car to a stop, but took an incredibly long distance to do so. A handful of warning lights popped on the screen when this happened: -Power train malfunction/reduced power - antilock brake fault - pre collision assist not available - hill start assist warning
May 18, 2025
AIR BAGS,VEHICLE SPEED CONTROL,SERVICE BRAKES
1 complaint
The contact owns a 2022 Ford Mustang Mach E. The contact stated that while driving approximately 20 MPH and pressing the brake pedal to stop, the vehicle suddenly accelerated forward and crashed into the rear of a second vehicle. Before the crash, the pre-collision warning had activated, but the vehicle did not stop. The front end of the had sustained severe damage but no bags deployed. No injuries were reported. A police report was taken at the scene, and the vehicle was later towed to a nearby collision facility. The cause of the failures has not yet been determined. The manufacturer and local dealer have not yet been contacted. The failure mileage was 19,100.
Apr 28, 2025
POWER TRAIN,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE
1 complaint
At highway speeds, the power brakes failed. In order to slow the car down, the brakes pedal had to be modulated with extreme force, upwards of 100 pounds of pressure on the brake pedal. As this happened, the car raised 4 Active Alerts - Powertrain Malfunction / Reduced Power - Antilock Brake Fault - Hill Start Assist Warning - Pre-Collision Assist Not Available. It took a lot of force and distance to bring the car safely to a stop. After 20 minutes we restarted the car and it began to operate normally. The car was brought to a nearby dealer immediately, however, the dealership is unable to diagnose nor replicate the problem. ***We were extremely lucky there were no cars immediately in front of us, and that we have an extreme amount of room to stop. Had we been driving in traffic, there would have been an extremely high likelihood of an accident with injury.
Sep 20, 2024
POWER TRAIN,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL
1 complaint
My car lunges forward randomly. I have called ford and went to ford several times.
Aug 15, 2024
POWER TRAIN,ENGINE,FORWARD COLLISION AVOIDANCE
1 complaint
Car was stopped at the top of a hill. Driver put the car in park and exited to talk to a security guard to raise a security barrier. Car began to roll down a hill and didn't stop until it hit a metal security gate 250 yards away. Car was totaled as result of collision with gate. No one was hurt. It would appear that the transmission/engine did not stay in park and began to roll and that none of the other safety features stopped the car. There were no passengers in the car at the time of the accident and no airbags went off.
Jul 31, 2024
STEERING,BACK OVER PREVENTION,LANE DEPARTURE
1 complaint
The contact owns a 2022 Ford Mustang Mach-E. The contact stated that while having the Blue Cruise system activated at approximately 70 MPH, the vehicle suddenly drifted to the right. The contact was able to straighten out the vehicle however, the vehicle drifted to the left and then to the right again. After a while, the contact was able to regain control of the vehicle by manually operating the steering wheel instead of using the Blue Cruise system to control the vehicle. The contact stated that shortly after regaining control of the vehicle, the failure recurred in the opposite direction going from left to right, and then to the left. There were no warning lights illuminated. The contact was able to maintain control. The dealer was contacted and was able to remotely pull the codes from the vehicle for diagnostic testing. The dealer diagnosed that the camera system and control modules had failed. The vehicle had not been repaired. The manufacturer was made aware of the failure. The manufacturer referred the contact to the dealer for servicing. The failure mileage was 30,000.
Apr 29, 2024
POWER TRAIN,ELECTRICAL SYSTEM,SERVICE BRAKES
1 complaint
Post HVBJB recall, one-pedal drive randomly disengages. Operators of electric cars vehicles use one pedal driving to slow down the vehicle and brake. When that system of braking randomly fails, it is incredibly unsafe. Ford is aware of this problem and it's connection to the earlier recall. I can provide additional documentation if necessary. Ford recognizes issue but has not fix.
Apr 24, 2024
ELECTRICAL SYSTEM,BACK OVER PREVENTION
1 complaint
The contact owns a 2022 Ford Mustang Mach-E. The contact stated while reversing(R) at approximately 2 MPH, the back-up camera image froze and then went black. The contact stated that the "Parking Assist" warning light illuminated and then a random game launched on the screen. The contact had taken the vehicle to a local dealer who was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 16,000.
Apr 11, 2024
VEHICLE SPEED CONTROL,UNKNOWN OR OTHER,FORWARD COLLISION AVOIDANCE
1 complaint
I have had 14 incidents over two years where this vehicle suddenly, rapidly accelerates from slow speed, usually less than 15 mph, and six of those incidents had a near collision. Most of the incidents happen in a parking lot or drive-thru and require immediate fast braking to avoid collision. This sudden, unexpected acceleration has been widely discussed on the Mach-E Forum and there is general agreement the cause is inadvertent engaging cruise control by accidentally hitting an overly sensitive button on the steering wheel when the hands are in the 9 to 3 position. I have reviewed all related threads on the forum and counted 36 different owners who have experienced this same problem, most reporting near collisions and serious concerns for safety. Some posters have described possible remedies.
Feb 03, 2024
STEERING,ELECTRICAL SYSTEM,AIR BAGS
1 complaint
The contact owns a 2022 Ford Mach-E. The contact stated that while driving at approximately 60 MPH the steering and braking systems suddenly malfunctioned causing the driver to lose control of the vehicle. The driver was unable to steer the vehicle and when pressing the brake pedal the vehicle did not stop. The driver lost control of the vehicle drove off the road and down a ravine and crashed into a concrete embankment. During the crash neither front air bags deployed. The front passenger sustained a fractured sternum and was transported from the scene to the hospital. The driver of the vehicle sustained a concussion which later required medical attention. A police report was taken at the scene and the vehicle was towed away. The cause of the failures was not yet determined. The manufacturer and local dealer were notified of the failure. The contact indicated that the vehicle was recently serviced for NHTSA Campaign number: 23V687000(Electrical System). The failure mileage was 9,100.
Jan 04, 2024
ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL
1 complaint
There is an issue with the vehicle displaying the speed when operating. I have experienced this issue randomly over the past year. The speed is typically displayed on the information cluster screen above the steering wheel. I have photo and video of the issue but the Upload File button is not working on your website. The only resolution so far has been to restart the vehicle. It does not appear that this can be resolved while the vehicle is ON.
Jan 02, 2024
VEHICLE SPEED CONTROL,ELECTRICAL SYSTEM
1 complaint
Ford did an update recently, 6.8.0, which obscures the speedometer and moved it to far right of the IPC making it difficult to see now when driving. This is safety issue and I like to have the speed of my vehicle right in front me where it should be.
Dec 20, 2023
STEERING,ELECTRICAL SYSTEM,ENGINE
1 complaint
Waiting for traffic to move in a busy street. Lights went up pedestrian sounder fault stop safely now and the vehicle wouldnt move. I was panicking my life is in danger im stuck between opposite traffic. So I put on the hazard lights and call two tow trucks and called 911. Next day high voltage warning and powertrain malfunction lights went up service now. I setup first available service which is in one week. Called ford said its okay to drive while waiting for the service. 12/14, warning lights disappeared in the morning but in the afternoon same thing happen lights went up pedestrian sounder fault stop safely now and it just stopped again in the middle of a busy street. I checked recall site there was no recall for this specific vehicle concerning this but others were recalled
Dec 15, 2023
ELECTRICAL SYSTEM,FORWARD COLLISION AVOIDANCE
1 complaint
Ford is aware of these issues and I can't believe they are ignoring them and making me pray through them. My vehicle, since I purchased it, has had issues with the adaptive cruise, the accident avoidance gets disabled, lane assist stops working, and the final thing is that it registers that the camera is not working and must be serviced. the last thing that happened is that the car shut down its self driving in the middle of taking a turn on the highway and proceeded to drive me off the road. There was no braking or anything, when I reacted to stop it, I barely missed the guard rail and the car fought me to even turn the wheel. This has been documented with multiple dealerships. All of them have dealt with Ford's technicians remotely and have all failed at fixing my issues. Before it everything stopped working again, it went on and off for months as it did before... the failed completely. Because of this, my wife and I only transport our children in her vehicle out of concerns for our family's safety. Ford will try to say they won't replace my vehicle due to its current milage, but this was well documented and never fixed long before this. its been happening since 2,000 miles.
Dec 11, 2023
UNKNOWN OR OTHER,VISIBILITY
1 complaint
The panoramic glass roof is slowly failing. The glass began to develop a small stress crack (with no sign or notice of impact as cause) which, over the months, has grown to a complete circle, about 12 inches in lengths. Additional stress cracks will easily compromise the glass and cause an immediate road safety hazard. Ford dealership denies any responsibility or warranty claim, falsely claiming it was due to some kind of impact when it was not.
Nov 28, 2023
VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE,LANE DEPARTURE
1 complaint
While driving on I-40 East between Raleigh, NC and Benson, NC I was trying to use the Blue Cruise self driving feature on my Mache. The system is frightening to me because it tends to default towards the marker between lanes and requires more attention than so called hands free driving is supposed to need. However, in this situation, there was a stretch of the highway where the lane markers were half white and then half black stripes. When I hit that stretch the car veered over the lane markers into the passing lane and if I hadn't resumed control, would have taken me completely into the other lane. The dash indicated that the system was in control of the car for the entire time. It had not disengaged at any point.
Sep 18, 2023
ELECTRICAL SYSTEM,UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM
1 complaint
While driving the vehicle in the highway the service/malfunction indicator light (MIL, wrench symbol) turned on and the vehicle dramatically lost propulsion power limiting my acceleration/speed. I opened the Ford Pass App on my phone and the following messages were shown regarding the issue: "High-Voltage Battery Warning and Powertrain Malfunction/Reduce Power". The message in the app also indicated to contact the dealer immediately. I would estimate that max acceleration was instantly reduced over 30%, causing a great concern while cruising at highway speeds. Previous to the date of this incident, the warning/check engine light never turned on. I made the next exit to use secondary roads as a precautionary measure since the max acceleration was limited. I am very active in various Mach-E forums, and this is a well-known issue for Ford. These messages are the ones related to a potential design problem with the High Voltage Battery Junction Box (HVBJB) included in my vehicle (Mach-Es built on or before May 28, 2023). My production date was January 2022. This vehicle got the safety recall #22S41 (software update) at the dealer last year. The software basically allowed the driver to get these warning messages if issues with the HVBJB contactors were detected. It is noteworthy to mention that I did not get the “Stop Safely Now” message, which would have made the vehicle undrivable. Next morning the wrench symbol disappeared from my instrument cluster. Ford issued a technical service bulletin #23-2257 to address a fix, which will involve the replacement of the potentially defective HVBJB for a redesigned one. The dealer indicated the remedy Ford provided was the software update, however multiple owners have reported the replacement of the potential defective part by Ford can only be done if the vehicle is totally inoperable showing the "Stop Safely Now" message. A sudden loss of propulsion while cruising at highway speeds is a safety concern for driver and others.
Sep 08, 2023
STEERING,LANE DEPARTURE
1 complaint
While driving on the freeway at about 65 mph through a gradual left bend in the road, with fully active SuperCruise (lane keeping, active cruise control) and fully hands off, the vehicle suddenly veered into the adjacent right lane. The vehicle moved into the adjacent lane at a high rate, and could have resulted in a heavy side impact to a vehicle driving in that lane (and potentially rippling into the lane to the right of that as well). Throughout the deviation, SuperCruise remained active without warning lamps or any inducement of driver takeover. I caught the malfunction and manually overpowered the steering to bring the vehicle back into the original driving lane. The vehicle has no active open recalls, and is operating with the latest firmware updates installed. The vehicle has not been inspected by dealer, manufacturer, or any other group for any relating issues.
Sep 01, 2023
ELECTRICAL SYSTEM,EQUIPMENT
1 complaint
Upon startup and without warning, the sound system emitted a very startling ear-piercing noise followed by very loud static which did not stop when radio was turned off. It finally stopped when I turned the car off but static started up again each time it was turned on. An hour later when the car was turned on it did not occur. It was so loud that the car was undrivable not to mention how startling it was at the onset. I actually jumped out of the car when it happened. I’ve scheduled a service visit for next week.
Aug 24, 2023
POWER TRAIN,ELECTRICAL SYSTEM,UNKNOWN OR OTHER
1 complaint
Was driving home, and all of a sudden I got a "Service Vehicle Soon" on the screen. and Got the following errors on FordPass App: 1- Powertrain Malfunction / Reduced Power 2- High-Voltage Battery Warning The time was around 8:30pm, the weather wasn't too hot not too cold. Was driving around 50 mph IIRC.
Aug 14, 2023
POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM
1 complaint
The HVBJB (high-voltage battery junction box) subassembly in ALL Ford Mach-e vehicles has known defects with insufficiently robust main contactors that are known to fail under normal charging and driving conditions as outlined in NHTSA Campaign Number 22V412000. Unfortunately, the internal damage to contactors is not visible externally, and warning notices on display only after damage has occurred, and can result in sudden loss of propulsion power at highway speed, loss of power steering, and power brakes, as well as failure of other 12V systems due to inability to charge the 12V battery properly after contactors are damaged. Less catastrophic results can include failure to start, which can strand drivers and passengers in remote areas, bad weather conditions, and also cause loss of use for weeks due to delays in replacement parts and local dealerships needing equipment and training to effect removal/replacement of faulty unit with a new, more robust HVBJB. My complaint is that Ford's recall under campaign 22V412000 is a software-only attempt to prevent future damage, and does not require the part(s) which are KNOWN to fail to be replaced with the re-designed components which are available, and have been used to repair failures under warranty. I have no way of inspecting the original equipment to evaluate current condition; and failure can result in sudden and unexpected loss of power, steering, and braking as well as potentially stranding me in unsafe conditions unable to restart my vehicle. I would like to see NHTSA strengthen the Ford recall to include both improved software AND removal/replacement of the HVBJB sub-assembly with the new, more robust parts without a known failure risk. Thank you very much for your time.
Mar 06, 2023
STEERING,ELECTRICAL SYSTEM,FORWARD COLLISION AVOIDANCE
1 complaint
Power steering went out including 10+ error / fault codes displaying on the dash on the vehicle after planned having vehicle towed but was back to normal after a restart. Exiting the parking lot at a low speed power steering failed again resulting in a low speed crash. After having it towed to dealership they reviewed software on the vehicle seeing vehicle has has fault codes and module errors for 3+ months on their Ford telemetries cloud system showing module and system errors every other day. Dealership asked if I ever got notice via vehicle or app about these errors which I never received. Ford Legal was notified and said vehicle did have a possible Bluecruise recall and nothing wrong with vehicle without having a Ford Engineer viewing the vehicle. My dealership still said cloud system showed all these errors which didn't seem be an issue to ford. My insurance said they'd make repairs but if my dealership said vehicle isn't safe they recommenced fix what is needed which Ford said 0 issues.
Oct 17, 2022
ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,ENGINE
1 complaint
THE BATTERY ENERGY CONTROL MODULE RECALL SOFTWARE UPDATE WAS COMPLETED ON MY VEHICLE ON SEPTEMBER 22ND 2022 AT 1203 PM AT GOSCH FORD OF HEMET. UPON LEAVING AROUND A MILE DOWN THE ROAD I WAS DRIVING AROUND A CORNER. WHILE IN THIS CORNER MULTIPLE THINGS HAPPENED AT THE SAME EXACT MOMENT. MY TRACTION LIGHT MOMENTARILY FLASHED ALONG WITH A SERVICE WRENCH. VEHICLE SKID PARTIALLY OFF-ROAD INTO THE DITCH. I LOST CONTROL FOR A BREIF MOMENT BUT WAS ABLE TO GAIN CONTROL BEFORE CRASHING. MY SPEED WAS DRASTICALLY REDUCED TO ABOUT 1/3 OF ITS NORMAL POWER. THE VEHICLE WOULD STILL DRIVE JUST MUCH SLOWER. UPON THIS HAPPENING I IMMEDIATELY TOOK MY VEHICLE BACK TO THE DEALERSHIP. THIS RECALL WAS VERY VAGUE. WHEN I WAS AT THE DEALERSHIP I INITIALLY ASKED THE FORD SERVICE SALESMAN DANIEL VENTURA IF THIS SOFTWARE CHANGED ANY ASPECT OF MY VEHICLES PERFORMANCE. HE THEN READ THE RECALL LETTER AND SAID IF IT DID IT NORMALLY WOULD SAY IT EITHER IN THE RECALL ITSELF OR THE LETTER FORD SENDS YOU THEY WOULD NORMALLYSAY IT IN IT. IT DID NOT MENTION THAT WHILE DRIVING THRU A CORNER IF YOU LOOSE POWER IN THE CAR DUE TO A BATTERY CONTROL MODULE FAILURE THAT YOU MAY LOOSE TRACTION AND LOOSE CONTROL OF THE CAR MOMENTARILY. THIS IS A VERY UNSAFE DRIVING CONDITION. FURTHERMORE WHEN I LEFT THE DEALERSHIP THE CAR DROVE DIFFERENTLY. IT SEEMED LIKE THE HORSE POWER WAS ABOUT 5-10 HP LESS THEN WHEN PURCHASED. IT FELT A LITTLE WEIRD TO GET USED TO DRIVING DOWN THE ROAD SINCE IT HAD A LITTLE BIT MORE PUSH THEN BEFORE. I MENTION THIS BECAUSE I BELIEVE THAT AS A CONSUMER I HAVE A RIGHT TO KNOW THE SOFTWARE THAT IS GOING INTO MY CAR. IF ANY ADVERSE REACTION THAT MAY CAUSE ME A DIFFERENT DRIVING EXPERIENCE OR PUT MY LIFE AT RISK OF CRASHING SHOULD HAVE BEEN INCLUDED IN THE SAFETY RECALL OR THE LETTER FORD HAD SENT US IN THE RECALL. I AM A FIRM BELIEVER THEY DO NOT WANT TO TELL US THAT THIS VEHICLE IS STILL NOT SAFE TO DRIVE AS WHAT HAPPENED TO ME HAVING THE BATTERY CONTROL MODULE FAILURE DURING CORNERING.
Sep 23, 2022
POWER TRAIN,VEHICLE SPEED CONTROL
1 complaint
The contact owns a 2022 Ford Mustang. The contact stated while pulling into a parking spot at approximately 2 MPH and had not yet placed the vehicle in park, the vehicle had an unintended acceleration. The contact stated no warning light was illuminated. The vehicle crashed into a light post, ran over the post, and crashed into a back of a building. The vehicle had damage to the hood, grill and bumper and also to the undercarriage. The contact said he had not suffered any injuries. The police were on the scene and filed a report. The contact had the vehicle towed to a collision repair shop. The vehicle had not been diagnosed by a dealer or independent mechanic. The vehicle had not been repaired. The contact researched online and related the failure to NHTSA Campaign Number: 22V333000 (Vehicle Speed Control, Power Train). The manufacturer had been informed of the failure. The failure mileage was approximately 7,500.
Sep 01, 2022
ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,UNKNOWN OR OTHER
1 complaint
Adaptive cruise control fault, pre-commission sensors not working, anti-lock break fault, restraint fault, tire pressure fault, dash turns off while driving which makes unable to see speed driving.
Aug 06, 2022
STEERING,ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM
1 complaint
The HVBJB subassembly in ALL Ford Mach-e vehicles has known defects with 'under-designed' main contactors that are known to fail under normal charging and driving conditions as outlined in current open Ford recall notice for my vehicle 22s41. Unfortunately, the internal damage to contactors is not visible externally, and warning notices on display only after damage has occurred, and can result in sudden loss of propulsion power at highway speed, loss of power steering, and power brakes... and failure of other 12v systems due to failure to charge the 12v battery properly after contactors are damaged. Less catastrophic results can include failure to start; which can 'strand' driver's and passengers in remote areas, bad weather conditions, as well as cause loss of use for weeks due to delays in replacement parts and local Dealerships needing equipment and training to effect removal/replacement of faulty unit with a new HVBJB having re-designed 'beefier' components. My complaint is that Ford's recall notice 22s41 is a software-only attempt to prevent future damage, and does not require removal of the part(s) which are KNOWN TO FAIL to be replaced with the re-designed components which are available, and have been used to repair failures under warranty. I have no way of inspecting the original equipment to evaluate current condition; and failure can result in sudden and unexpected loss of power, steering, and braking as well as potentially 'stranding me' in unsafe conditions unable to re-start my vehicle.? ? I would like to see NHTSA strengthen the Ford recall to include both improved software AND removal/replacement of the HVBJB sub-assembly with the new 'beefier' parts.
Jul 10, 2022
Where to Find VIN for Problems Check
To check for problems and complaints on your 2022 FORD Mustang Mach-E, you'll need the VIN number. Find your VIN in one of these 4 common locations.
Understanding VIN Structure for Problem Reports
Each character in your 2022 FORD Mustang Mach-E 17-digit VIN helps identify specific complaints and problems affecting your vehicle model.
How to Check 2022 FORD Mustang Mach-E Problems in 3 Steps
1
Locate Your VIN
Find the 17-character VIN on your 2022 FORD Mustang Mach-E dashboard (visible through windshield), door jamb, engine bay, or vehicle documents.
2
Review by Component
Browse owner-reported complaints organized by vehicle component (engine, transmission, brakes, electrical) to identify common issues and problem patterns for this model year.
3
Check Safety Issues
Review crash and fire incidents for each component to assess safety concerns. Contact your FORD dealer or report problems to NHTSA at SaferCar.gov.
Frequently Asked Questions
How many problems does the 2022 FORD Mustang Mach-E have?
The 2022 FORD Mustang Mach-E currently has 115 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.
What are the most common problems with 2022 FORD Mustang Mach-E?
The most common problems reported for the 2022 FORD Mustang Mach-E are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.
Where does this 2022 FORD Mustang Mach-E problem data come from?
All problem and complaint data for the 2022 FORD Mustang Mach-E comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.
How do I report problems with my 2022 FORD Mustang Mach-E?
You can report safety problems with your 2022 FORD Mustang Mach-E directly to NHTSA at SaferCar.gov or call 1-888-327-4236. Your complaint helps identify patterns and may lead to recalls or investigations.
Where can I find my VIN to check problems?
Your 2022 FORD Mustang Mach-E VIN is located in 4 places: (1) Dashboard near windshield on driver's side, (2) Driver's door jamb sticker, (3) Engine bay, (4) Vehicle registration and insurance documents.
Is the 2022 FORD Mustang Mach-E reliable?
Reliability can be assessed by reviewing the number and severity of owner complaints for the 2022 FORD Mustang Mach-E. Check complaints by component, crash reports, and fire incidents above to evaluate potential issues and problem patterns.
Other Years - FORD Mustang Mach-E Problems
2024
2023
2021
2020
2019
2018
2017
2016
2015
2014
2013
2012
2011
2010
2009
2008
2007
2006
2005
2004
2003
2002
2001
2000
1999
1998
1997
1996
1995
1994
1993
1992
1991
1990
Other FORD Models
'34
1500 Foldaway
A8513
A9513
A9522
Aerostar
Affordable Aluminum
Affordable Trailers
Aspire
AT8513
AT9513
AT9522
Similar Brands
ST
3,555 models
RS
3,484 models
NC
2,822 models
ND
2,385 models
Z
1,951 models
MOTO
1,583 models
NU
1,189 models
RC
1,122 models