1997 FORD Ranger Problems & Complaints
Real owner complaints and problems reported to the National Highway Traffic Safety Administration (NHTSA). View common issues by component.
453
Complaints Reported
Complaints by Component
TIRES
60 complaints
I HAD FIVE (5) BF GOODRICH RADIAL ALL TERRAIN TA TIRES FAIL WHILE DRIVING THE SAME VEHICLE OVER ABOUT A TEN YEAR PERIOD. EACH FAILURE IS THE SAME. THE STEEL BELT OF THE TIRE PARTIALLY SEPARATES WHILE ROLLING. THE FIRST OCCURRED ABOUT TEN YEARS AGO ON THE INTERSTATE WHILE PULLING A SMALL FLATBED TRAILER. STEEL BELT THEN WHIPS AROUND INSIDE WHEEL WELL DAMAGING WHATEVER IT COMES IN CONTACT WITH. BF GOODRICH RADIAL ALL TERRAIN TA TIRES WERE ON THIS TRUCK WHEN PURCHASED USED. SECOND TIRE FAILED APPROXIMATELY THREE YEARS AGO THE SAME WAY AT LESS THAN 30 MPH. REPLACED ALL WITH USED SET OF FOUR TIRES WITH 50 % TREAD LEFT. LESS THAN A MONTH AFTER, THIRD TIRE FAILED ON INTERSTATE ONCE AGAIN IN THE SAME WAY. STEEL BELT CUT THE FIBERGLASS REAR OUTER FENDER IN HALF, RIPPED OUT THE REAR WIRING HARNESS, DESTROYED THE LEFT TAIL LIGHT, AND EVEN DAMAGED THE GASOLINE FILL TUBE AND DESTROYED ITS LOCKING GAS CAP FROM THE FORCE OF THE BELT WHIPPING ROUND AND ROUND THE WHEEL, PARTIALLY ATTACHED AND PARTIALLY OFF. NEARLY LOST CONTROL OF VEHICLE, BUT WAS NOT INVOLVED IN ACCIDENT. ALL TIRES FAILED WHILE IN DRIVER'S REAR WHEEL POSITION. THEN LAST MONTH AGAIN, THE LEFT REAR BF GOODRICH RADIAL ALL TERRAIN TA TIRE STEEL BELT CAME PARTIALLY OFF AT ABOUT 30 MPH. EACH TIME A USED TIRE REPLACED THE FAILED TIRE. THEN TWO DAYS LATER, A FIFTH BF GOODRICH RADIAL ALL TERRAIN TA BEGAN TO FAIL WITH STEEL BELT COMING APART. THIS TIME RIGHT REAR WHEEL LOCATION. NOTICED THE FAILURE BEFORE STEEL BELT CAME COMPLETELY OFF AND ANY DAMAGE WAS DONE. REPLACED WITH BF GOODRICH MUD TERRAIN TA THAT WERE ALSO USED BUT HAVE NOT FAILED.
Jun 21, 2017
TL* THE CONTACT OWNS A 1997 FORD RANGER EQUIPPED WITH BRIDGESTONE DUELER AT TIRES, LINE SIZE 225/70/R14 . THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, HE BEGAN TO HEAR A THUMPING NOISE. THE VEHICLE WAS DRIVEN HOME WHERE THE CONTACT NOTICED THAT THE TREAD ON THE REAR DRIVER SIDE TIRE WAS PEELING. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 131,000.
Aug 24, 2011
TL*THE CONTACT OWNS A 1997 FORD RANGER. THE CONTACT PURCHASED NEW GOODYEAR MOHAVE R/S (NA), SIZE P215/70R/14 TIRES IN OCTOBER OF 2005. WHEN THE VEHICLE WAS TAKEN TO THE SHOP FOR MAINTENANCE IN MAY OF 2007, THE MECHANIC STATED THAT THE TREAD WAS SEPARATING AND THE TIRES NEEDED TO BE REPLACED. THE CONTACT RECEIVED A NOTICE THAT OFFERED HER REPLACEMENT TIRES, IF THEY QUALIFIED. SHE CALLED THE MANUFACTURER AND THEY STATED THAT THEY WOULD CALL HER BACK. THE VEHICLE WAS RARELY DRIVEN AND THE CONTACT FELT THAT THE TIRES SHOULD NOT HAVE FAILED. THE FAILURE MILEAGE AND DOT NUMBER WERE UNKNOWN. THE CURRENT MILEAGE WAS 93,697.
Dec 12, 2007
TL*THE CONTACT OWNS A 1997 FORD RANGER. THE VEHICLE HAS BRIDGESTONE DUELER APT III P225/70R14 DOT# Y7FCPT40207. WHILE DRIVING 70 MPH AND ATTEMPTING TO CHANGE LANES, THE FRONT DRIVER SIDE TIRE BLEW OUT. THE CONTACT TEMPORARILY LOST CONTROL OF THE VEHICLE, BUT WAS ABLE TO DECELERATE AND PULL OFF THE ROAD. HE REPLACED THE TIRE AND FOUND THAT THE TREAD HAD SEPARATED. THE CURRENT MILEAGE IS 109,170 AND FAILURE MILEAGE WAS 109,130. THE CONSUMER STATED A BRAND NEW TIRE BLEW OUT WHILE ON THE FREEWAY REPLACED ALL 4 TIRES. UPDATED 08/24/07 *TR
Jul 03, 2007
MY SEVENTEEN YEAR OLD SON WAS DRIVING HOME FROM WORK ON SUNDAY, SEPTEMBER 26, 2004 IN HIS 1997 FORD RANGER PICK-UP. HE WAS HEADED EAST ON I-240 WHEN HIS TRUCK SUDDENLY BEGAN TO SWERVE OUT OF CONTROL. HE SOMEHOW MANAGED TO BRING HIS VEHICLE TO A STOP SAFELY, WITHOUT A COLLISION. AFTER GETTING OUT TO INSPECT HIS VEHICLE HE FOUND THAT HIS RIGHT REAR TIRE WAS THE CAUSE. THE TIRE, A FIRESTONE 14" WITH PLENTY OF TREAD, HAD SEPARATED (IE. THE TREAD HAD SEPARATED FROM THE TIRE). THE TIRE WAS STILL COMPLETELY FULL OF AIR EVEN AFTER THIS SEPARATION. THE SEPARATION OF THE TREAD CAUSED SEVERE DAMAGE TO THE TRUCK (APPROX. $1700.00). THERE WAS NO COLLISION AND THE TIRE DID NOT BLOW OUT, THE TREAD JUST PEELED OFF FOR NO APPARENT REASON.
Sep 30, 2004
+ 55 more complaints for this component
FUEL SYSTEM, GASOLINE
53 complaints
TL* THE CONTACT OWNS A 1997 FORD RANGER. THE CONTACT STATED THAT THE REAR FUEL STRAP WAS COMPLETELY RUSTED AND DETACHED FROM THE VEHICLE. THE FRONT FUEL STRAP WAS ALSO RUSTED. THE CONTACT SPOKE WITH THE DEALER AND WAS TOLD THERE WERE NO RECALLS FOR THE FUEL STRAPS ON THE VEHICLE AND PROVIDED NO FURTHER ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE AND THE CURRENT MILEAGE WAS 225,000.
Jan 30, 2012
THE GAS TANK STRAPS ON MY 1997 RANGER HAVE RUSTED THROUGH DROPPING THE FUEL TANK WHILE I WAS PULLING INTO MY DRIVEWAY. BOTH THE FRONT AND REAR STRAP HAVE RUSTED THROUGH. THE TANK IS BEING HELD UP WITH COMMERCIAL GRADES STRAPS. IS THIS MODEL BEING INCLUDED IN THE RECENT FORD RECALL ANNOUNCEMENT? I DID NOT SEE THE EXTENDED CAB RANGER MODEL MENTIONED.
Aug 02, 2011
FUEL TANK STRAPS FAILED DUE TO CORROSION/RUST CAUSING FUEL TANK TO PARTIALLY FALL. DEFECTIVE STRAPS WERE REPLACED WITH NEW ONES. *KB
Aug 01, 2011
WITHIN THE PAST TWO MONTHS I HAD A SPLIT IN THE FLEXIBLE FUEL FILLER PIPE ON MY 1997 FORD RANGER XLT. IN THE COURSE OF HAVING IT REPLACED, THE REPAIR SHOP REMOVED THE GAS TANK AND FOUND THE SAME CONDITION WITH THE METAL STRAPS THAT HOLD THE GAS TANK IN PLACE, EXTENSIVE CORROSION AS REPORTED ON THE FORD F150. IT APPEARS THE POSSIBILITY OF GAS TANKS DROPPING OUT OF THE VEHICLE MAY BE MORE EXTENSIVE THAN THE INITIAL REPORTS AND MAY APPLY TO OTHER FORD PICK-UP TRUCKS. *TR
May 10, 2011
FUEL LINE CRACKED ABOVE GAS TANK . STRONG GAS ODOR AFTER DRIVING OR DURING REFILL -GAS WILL SPILL OUT WHEN FILLING TANK UP TO FULL AND GAS SMELL CAN ALSO BE SMELLED DURING COMMUTE. WILL BE TAKING IT IN TO GREENWAY FORD DEALERSHIP HERE IN ORLANDO THIS WEEK. *TR
Mar 01, 2011
+ 48 more complaints for this component
POWER TRAIN
32 complaints
TL* THE CONTACT OWNS A 1997 FORD RANGER. THE CONTACT STATED THAT ONE MINUTE AFTER STARTING, THE VEHICLE FAILED TO SHIFT INTO GEAR AND THE VEHICLE STALLED. THE VEHICLE WAS NOT TAKEN TO THE DEALER, HOWEVER THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 181,000 AND THE CURRENT MILEAGE WAS 181,760.
Aug 11, 2011
THE ENGINE OCCASIONALLY RACES (RUNAWAY ACCELERATION) ON MY 1997 FORD RANGER 4X4 WITH STANDARD TRANSMISSION AND OVERDRIVE AND 3.0L ENGINE. THE ACCELERATION TENDS TO OCCUR AFTER I HAVE DRIVEN THE VEHICLE AT HIGHWAY SPEEDS (70 MPH) AND THEN DRIVE AT SLOWER SPEEDS SUCH AS IN AN URBAN SETTING. AT SUCH TIMES, THE IDLE REMAINS RATHER HIGH AND ENGINE RACING OCCURS WHEN I ENGAGE THE CLUTCH TO SHIFT INTO SECOND OR THIRD GEAR. THE ENGINE RACING CAUSES THE GEARS TO CLASH (GRIND) AND RESIST SHIFTING; I HAVE ALMOST BEEN REAR ENDED SEVERAL TIMES DUE TO THIS SLOWING OF FORWARD MOTION SINCE THE BRAKE LIGHTS DO NOT COME ON TO INDICATE IT. SOMETIMES THE ACCELERATION RUNS AWAY, AND I HAVE HAD TO QUICKLY PULL OVER AND TURN OFF THE IGNITION TO PREVENT BLOWING THE ENGINE. I HAVE TAKEN THE PROBLEM TO SEVERAL MECHANICS INCLUDING FORD, BUT NONE HAVE BEEN ABLE TO IDENTIFY THE CAUSE. THERE EVIDENTLY WAS A RECALL FOR AUTOMATIC TRANSMISSIONS WITH A SIMILAR PROBLEM BUT NOT FOR STANDARD TRANSMISSIONS. *TR
Apr 14, 2010
THIS TRUCK ACCERLERATES BY ITSELF, IT USED TO ONLY BE BETWEEN 2ND AND 3RD GEARS BUT NOW I CAN BE ON THE FREEWAY AND IN 4TH GEAR WHEN I CAN FEEL THE PEDAL GO DOWN TO THE FLOOR, I'M FORCED TO PUT IT IN NUETRAL UNTIL THE RPMS GO DOWN, TRYING TO GET IT INTO ANOTHER GEAR ONLY GRINDS BECAUSE ITS RUNNING TOO HIGH. THIS IS A SAFETY ISSUE, IF IT HAPPENS AT THE WRONG TIME SOMEONE COULD GET HURT OR THE ENGINE WILL JUST BLOW UP! *AK
Dec 26, 2004
MY '97 FORD RANGER STANDARD TRANSMISSION EXHIBITS HIGH IDLE CONDITIONS WHILE SHIFTING BETWEEN GEARS. MY DEALER WAS NEVER ABLE TO FIX THE PROBLEM SINCE I BOUGHT THE VEHICLE NEW. MY VEHICLE IS NO LONGER UNDER BUMPER TO BUMPER AND EMISSIONS WARRANTY BUT I HAVE SAVED RECEIPTS OF THEIR ATTEMPTS TO FIX THE PROBLEM DURING TIME VEHICLE WAS WARRANTED BACK IN 1997. I RECENTLY DISCOVERED THAT THE FORD MOTOR COMPANY HAS FOUND THE EXACT SAME HIGH IDLE PROBLEM WITH THEIR 1998 TO 2000 MODEL RANGERS AND THEY ISSUED A TECHNICAL SERVICE BULLETIN TSB00-3-5. WHEN I CALLED MY DEALER TO INQUIRE AND ASK THEM TO INCLUDE MY '97 RANGER IN THE BULLETIN, THEY WERE EVASIVE AND WOULDN'T HELP. I WOULD LIKE TO KNOW WHAT MY OPTIONS ARE. ANY HELP GREATLY APPRECIATED. THANK YOU. P.S. FOR YOUR INFO, THE TECHNICAL SERVICE BULLETIN CAN BE FOUND AT ( CASE SENSITIVE, PLEASE TYPE EXACTLY) V8SHO.COM/SHO/TSB00-3-5.HTML . *NLM
May 11, 2003
NO SUMMARY. DT
Nov 23, 2002
+ 27 more complaints for this component
SERVICE BRAKES, HYDRAULIC
31 complaints
MULTIPLE FAILURES OF FRONT ROTORS- STEPPED ON BRAKES- AND PULSES AND SHAKES, REMOVED TIRE TO CHECK ROTORS- ROTOR CRACKED- SAME SCENARIO EACH TIME- PASS SIDE 1ST TIME 30K (AUGUST 1999), 2ND TIME 48K(APRIL 2001) , 3RD TIME 58K, PADS FAILED- REPLACED NOV 2001, AND JAN 2002- REPLACED CALIPER AND PADS.- NOW HAS 84K AND SO FAR OK. 1ST TIME CHANGED BY FORD UNDER WARRANTY- 2ND TIME 18 MONTHS LATER- FORD DEALER CHARGED $600 + FOR NEW ROTORS- 3RD AND 4TH TIME I CHANGED - ALONG WITH CALIPER -EACH TIME DEALER ASKED TO CHECK TO MAKE SURE THAT WHATEVER IS CAUSING THE ROTOR TO FAIL- PLEASE CORRECT- EACH TIME THEY SAY - JUST A BAD ROTOR----AND WHEN THE 48K FAILURE OCCURED- FORD CLAIMED TO NOT HAVE A RECORD OF THE REPAIR- THOUGH IT WAS DONE UNDER WARRANTY-FINALLY AFTER THE 3RD FAILURE- FIGURED IT MADE MORE SENSE TO FIX IT MYSELF- RATHER THAN PAY A DEALER $650, AND HAVE IT FAIL AGAIN IN 18000 MILES. *AK
Sep 07, 2004
PROBLEMS WITH RUBBER HOSE, RUST AND CORROSION TO THE METALLIC BRAKE LINES.*MR *CB
Jul 28, 2003
CONSUMER STATED THAT WHEN APPLYING THE BRAKE THE BRACKET SNAP CAUSING A VEHICLE ACCIDENT. DEALER NOTIFIED. TS
Dec 04, 2002
WHEN APPLYING BRAKES VEHICLE WILL START TO SHAKE AND MAKE NOISE, HAS HAD ROTORS REPLACED ONCE ALREADY. CONTACTED DEALER. *AK
Apr 25, 2002
WHILE CONSUMER WAS DRIVING IN A 20 MPH ZONE ABS LIGHT CAME ON. THERE HAS BEEN OTHER TIMES THAT LIGHT CAME ON. THIS PROBLEM HAPPENED AT ANY SPEED . CONTACTED DEALER, AND DEALER SAID THERE WAS NOTHING THEY COULD DO. THIS IS WAS SECOND TIME THAT VEHICLE WAS TAKEN IN FOR SAME PROBLEM. *AK
Feb 22, 2001
+ 26 more complaints for this component
VISIBILITY
23 complaints
HEATER PLENUM (DOOR TO REGULATE HEAT TO CABIN) HAS BROKEN AND BURNED OUT CONTROL MOTOR CAUSING INTERIOR HEAT TO BE ALWAYS ON FULL HEAT
Jan 10, 2003
NO SUMMARY. DT
Nov 08, 2002
WINDSHIELD WIPER AND WINDSHIELD CLEANER COMES ON ALL BY ITSELF. *AK
Jul 10, 2001
WHILE DRIVING AND WITHOUT PRIOR WARNING WINDSHIELD WIPERS COME ON WITHOUT OPERATOR TURNING ON WIPER SWITCH. NOTICED THAT WINDSHIELD WIPERS STAY ON FOR 15 SECONDS, AND THEN TURN OFF, CAUSING DRIVER DISTRACTION. CONSUMER HAS CONTACTED DEALER, DEALER REPLACED PARTS WITHIN SWITCH.*AK
Jun 14, 2001
WINDSHIELD WIPERS AND WASHERS WILLSTART UP AT ANY TIME. AT ONE POINT I ALMOST HIT THE CAR IN FRONT. *AK
Jan 16, 2001
+ 18 more complaints for this component
SUSPENSION
21 complaints
REAR LEAF SPRING HANGERS/SHACKLES RUSTED OFF AS WELL AS THE FRONT ONES ON THE REAR LEAF SPRINGS. SPARE TIRE CARRIER FELL DOWN DRAGGING THE SPARE TIRE ACROSS THE ROAD. ONE CROSSMEMBER HOLDING UP THE FRONT OF THE GAS TANK IS READY TO GO. BOTH GAS TANK STRAPS ROTTED OFF. TOYOTA WAS MADE TO FIX THESE ISSUES. WHY NOT FORD? I WORK AT A TOYOTA DEALERSHIP REPLACING ROTTEN FRAMES ON TUNDRAS, SEQUOIAS, AND TACOMA VEHICLES. THERE IS NO DIFFERENCE AS BOTH THE FRAMES FOR TOYOTA AND FORD ARE BUILT AT THE SAME FACTORY IF I AM CORRECT? THE VEHICLE WAS BEING DRIVEN DOWN THE ROAD ALL TIMES THE ABOVE LISTED FAILED. SOME TIMES ON THE HIGHWAY, OTHERS IN TOWN. I DO NOT FEEL SAFE SELLING THIS VEHICLE TO ANOTHER INDIVIDUAL WHEN IT'S READY TO GO.
Oct 13, 2015
DRIVING DOWN ROAD REAR SPRING BROKE ANOTHER TIME SPAR TIRE CAME OF ALMOST CAUSING CRASH ,HAVE REPAIRED BOTH REAR SPRING BRACKETS ,TWO FRONT SUSPENSION , LOST SPARE AND FRAME ABOUT TO BRAKE AWAY . WHAT SHOULD I DO . HAVE LOT OF MONEY INVESTED . *TR
Nov 07, 2011
WHILE WORKING ON AND DOING AN UNDERBODY INSPECTION I NOTICED THAT THE DRIVERS SIDE REAR SPRING HANGER IS ALMOST ROTTED COMPLETELY THROUGH. IT IS A CAUSE FOR ALARM FOR ME AND ANYBODY DRIVING NEAR ME ON THE HIGHWAY. IF NOT FIXED IT COULD POSSIBLY CAUSE A DEADLY ACCIDENT. THE PASSENGER SIDE IS ROTTED AS WELL. FRONT SUSPENSION IS ROTTING AS AT A FAST RATE. THE TRUCK SEEMS TO JUMP INTO OTHER LANES AFTER HITTING POT HOLES OR OTHER ROAD HAZARDS. *TR
Oct 18, 2011
WHILE GOING DOWN HILL AND AROUND A CURVE HEARD A LOUD NOISE FROM REAR AND FELT BACK OF TRUCK MOVE SIDE WAYS. A SHORT TIME AFTER, ANOTHER LOUD NOISE FROM REAR AND REAR OF TRUCK DROPPED LOW . I LOST CONTROL AND WENT ONTO SHOULDER AND SLOWED DOWN WAS ABLE TO RECOVER AND AT SLOW SPEED WENT HOME. ON INSPECTION FOUND BOTH REAR LEAF SPRING FORWARD SHACKLE SUPPORTS FAILED DUE TO CORROSION. WAS LUCKY NOT GOING FASTER AS COULD HAVE RESULTED IN VERY SERIOUS CRASH. PLEASE INVESTIGATE AND WARN OWNERS OF POSSIBLE FAILURE OF LEAF SPRING. AND LOSS OF CONTROL TRUCK IS PARKED AND NOT ABLE TO BE DRIVEN. *TR
Sep 08, 2011
1997 FORD RANGER DRIVER SIDE REAR SPRING HANGER RUSTED AWAY & BROKE CAUSING WEIGHT OF VEHICLE TO BE CARRIED BY TRUCK BED FLOOR. *TR
Aug 08, 2011
+ 16 more complaints for this component
INTERIOR LIGHTING
20 complaints
THE RELAY TO THE DOME LIGHT SHORTED OUT. IT'S HAPPENED TWICE. I KNOW 3 OTHER PEOPLE WHO ALSO DRIVE RANGERS , AND HAVE ALL HAD THE SAME PROBLEM. ONE OF THEM HAS HAD THE SAME FAILURE TWICE. *AK
Mar 10, 2005
DOME LIGHTS STAYS ON FOR EXTENDED PERIODS OF TIME. I HAD TO REMOVE THE BULBS, NOW I HAVE NO DOME LIGHT.*AK
Jul 27, 2004
DOME LIGHT STAYS ON, AND THE DOOR AJAR LIGHT COMES ON INTERMITTENTLY. THIS PROBLEM EXISTED AFTER THE WARRANTY EXPIRED. VEHICLE WAS NOT REPAIRED CORRECTLY THE FIRST TIME. *AK *MR
Feb 19, 2004
THE INTERIOR LIGHT IN MY TRUCK DOES NOT GO OUT WHEN THE DOOR IS SHUT AND THE ENGINE IS RUNNING. *LA
Oct 24, 2003
INTERIOR DOME LIGHT STAYS ON. ALSO HAD THE SAME PROBLEM WITH MY 1994 FORD RANGER. *AK
Oct 25, 2001
+ 15 more complaints for this component
AIR BAGS
19 complaints
TAKATA RECALL -- I BELIEVE ALL AIRBAGS ARE DEFECTIVE AND MORE DANGEROUS THAN RIDING WITH SEAT BELTS ALONE. I RECOMMEND 100% DISABLING OF AIRBAGS AND THE REMOVAL OF ALL AIRBAGS AND ASSOCIATED HARDWARE FROM FUTURE VEHICLES.
Jul 19, 2017
WE WERE DOING 30MPH AND WE HIT A SHEET OF BLACK ICE. THEN WE HIT THE GUARDRAIL. WHEN WE HIT THE DRIVER SIDE AIR BAG DID NOT GO OFF UNTIL THE VEHICLE STOPPED AND THE PASSENGER SIDE AIR BAG DID NOT GO OFF. *TR
Feb 07, 2013
THERE WAS A THREE VEHICLE ACCIDENT AT 50 MPH. THE CONSUMER'S AIR BAG DID NOT DEPLOY. *SC *TC *JB
Jan 05, 2005
I HAD JUST PUT MY TRUCK INTO DRIVE WHEN THE AIRBAG DEPLOID BY ITSELF WHICH CAUSED INJURY TO MY HAND
Jul 19, 2004
VEHICLE WAS IN A VERY SEVERE FRONT/SIDE COLLISION. VEHICLE WAS TOTALED, BUT NONE OF THE AIR BAGS DEPLOYED UPON IMPACT.*AK
Jun 26, 2003
+ 14 more complaints for this component
VEHICLE SPEED CONTROL
19 complaints
TL* THE CONTACT OWNS A 1997 FORD RANGER. THE CONTACT STATED THAT THE SPEED CONTROL SWITCH MELTED. THE CONTACT STATED THAT HE HAD NOT EXPERIENCED A FAILURE PRIOR TO THE VEHICLE BEING REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 09V399000 (VEHICLE SPEED CONTROL). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000.
Nov 23, 2015
TL* THE CONTACT OWNS A 1997 FORD RANGER. THE CONTACT STATED THAT THE VEHICLE WOULD LOSE POWER SPORADICALLY BEFORE ABNORMALLY ACCELERATING. THE CONTACT STATED THAT WHEN THE FAILURE OCCURRED, THE FAILURE COULD NOT BE STOPPED BY APPLYING THE BRAKES. IN ADDITION, THERE WAS AN ABNORMAL SPIKE IN ENGINE RPMS WHEN THE FAILURE OCCURRED. THE VEHICLE WOULD CORRECT ITSELF SHORTLY THEREAFTER. THE FAILURE MILEAGE WAS 126,000 AND THE CURRENT MILEAGE WAS 136,252.
Jan 17, 2012
TODAY MY ACCELERATOR FAILED. I WAS SITTING AT A RED LIGHT. I WENT TO ACCELERATE BY PUSHING ON THE ACCELERATOR PEDAL WITH MY RIGHT FOOT. THERE WAS NO ACCELERATION. THE ACCELERATOR PEDAL HAD FAILED. FURTHER INVESTIGATION REVEALED THREE SPOT WELDS THAT HELD A PLATE TO THE FIREWALL HAD FAILED. THE ACCELERATOR PEDAL PIVOTS ON THIS PLATE AND ATTACHED BOLT. I WAS ABLE TO DO A TEMPORARY REPAIR TODAY. BUT, THE FAILURE IN TRAFFIC WAS VERY DANGEROUS. *TR
Nov 21, 2011
TL* THE CONTACT OWNS A 1997 FORD RANGER. THE CONTACT ATTEMPTED TO ENGAGE THE CRUISE CONTROL AT 55 MPH, BUT TO NO AVAIL. PRIOR TO THE FAILURE, THE CONTACT RECEIVED REPAIRS UNDER NHTSA RECALL CAMPAIGN ID NUMBER: 09V399000 (VEHICLE SPEED CONTROL). THE CONTACT STATED THE FAILURE SURFACE IMMEDIATELY AFTER RECALL REPAIRS. THE FAILURE MILEAGE WAS 95,000 AND THE CURRENT MILEAGE WAS 96,000.
Jun 24, 2010
I AM WRITING TO COMPLAIN ABOUT NOT HAVING MY VEHICLE SERVICE, AND I RECEIVED A RECALL LETTER. I WENT TO THE LEONARDTOWN DEALERSHIP ON WEDNESDAY, NOVEMBER 23, 2009, WITH MY LETTER FOR RECALL, AND WAS GIVEN INSTRUCTIONS ON HOW TO DISCONNECT THE SPEED DEACTIVATION SWITCH. I EXPLAINED TO THE SERVICE ADVISOR MR. JOHN JARBOE THAT MY VEHICLE HAS BEEN LEAKING BRAKE FLUID, BRAKE LIGHTS HAVE BEEN COMING ON AND I WANTED TO KNOW IF THIS DEFECTIVE SWITCH HAD ANYTHING TO DO WITH IT. HE SHOWED ME A DIAGRAM OF THE SWITCH, WHERE IT IS LOCATED NEAR THE MASTER CYLINDER AND TOLD ME THAT I CAN DISCONNECT IT MYSELF, AND IF I WANTED TO HAVE THE VEHICLE TOWED IN THEY WOULD LOOK AT THE OTHER PROBLEM. I THOUGHT FORD IS RESPONSIBLE FOR DOING THIS REPAIR NOT ME. I CAN'T DRIVE THE VEHICLE BECAUSE IT IS LEAKING BRAKE FLUID. I WAS TOLD THAT I CAN HAVE IT TOWED IN AND THEY WOULD LOOK AT THE PROBLEM. I AM NO SURE IF THIS SWITCH IS THE PROBLEM, BUT EVEN IF IT ISN'T ARE THEY SUPPOSED TO DEACTIVATE THE SWITCH NOT ME. I AM NOT A MECHANIC. *TR
Nov 26, 2009
+ 14 more complaints for this component
STRUCTURE
18 complaints
TL* THE CONTACT OWNS A 1997 FORD RANGER. THE CONTACT STATED THAT WHILE HAVING A ROUTINE INSPECTION AT HALDEMAN FORD OF KUTZTOWN, INC. (15465 KUTZTOWN RD, KUTZTOWN, PA 19530, (610) 683-3553) THE MECHANIC DETERMINED THAT THE FRONT AND REAR SUBFRAME WAS SEVERELY CORRODED. AFTER HAVING AN EMISSIONS INSPECTION, THE VEHICLE WAS DEEMED UNSAFE TO DRIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 154,000.
Feb 17, 2021
TL* THE CONTACT OWNS A 1997 FORD RANGER. UPON INSPECTION, IT WAS DISCOVERED THAT THE FUEL TANK WAS NOT SECURED AND WAS HANGING FROM THE SUBFRAME OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FAILURE WAS CAUSED BY SEVERE RUSTING AND CORROSION OF THE SUBFRAME. THE FAILURE WAS NOT REPAIRED. THE LOCAL DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 233,479. *TT
Jun 12, 2018
EXCESSIVE RUST NOT CAUSED BY NORMAL WEAR AND TEAR, HAD SPARE TIRE CARRIER RUST OFF WHILE ON THE ROAD
Mar 18, 2018
FARMR RUSTED THROUGH TRUCK WAS SITTING AT HOME PARKED WHEN IT BROKE THROUGH
Apr 06, 2017
I WALKED OUT OF MY HOUSE ONE MORNING AND MY REAR BUMPER WAS LAYING ON THE GROUND BEHIND MY TRUCK. *TR
Jan 31, 2015
+ 13 more complaints for this component
STEERING
16 complaints
TL*THE CONTACT OWNS A 1997 FORD RANGER. WHILE TRAVELING 10 MPH ATTEMPTING A LEFT HAND TURN THE CONTACT NOTICED THAT THE STEERING WHEEL WOULD NO LONGER RESPOND CAUSING THE CONTACT TO LOSE CONTROL OF THE VEHICLE. THE STEERING WHEEL COULD BE TURNED IN ANY DIRECTION BUT THE WHEELS WOULD NOT RESPOND TO THE MOVEMENT. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE STEERING BOX HAD SEPARATED FROM THE VEHICLE. THERE WERE NO PRIOR WARNINGS AND THE FAILURE WAS NOT DIAGNOSED. THE CURRENT AND FAILURE MILEAGES WERE 85000.
Aug 13, 2010
DRIVER SIDE TIE-ROD SEPERATION '97 FORD EXPEDITION WHILE DRIVING AT 50 MPH ON HIGHWAY. LOSE OF STEERING CONTROL. SERIOUS ACCIDENT AVOIDED ONLY BECAUSE OF EMERGENCY BRAKING.
Jul 27, 2005
THE CONSUMER VEHICLE LOST CONTROL OF THE VEHICLE AND ROLLED OVER. PLEASE PROVIDE ANY FURTHER INFORMATION. *JB
Apr 22, 2005
WHILE DRIVING 55 MPH VEHICLE LOST CONTROL AND ROLLED OVER. AS A RESULT, THE ROOF CRUSHED IN AND BROKE THE DRIVER'S NECK. VEHICLE WAS CONSIDERED A TOTAL LOSS. *AK
Apr 06, 2005
I HAVE A 1997 FORD RANGER XLT SUPERCAB, 2.3L 4X2. I WAS PULLING OUT OF MY PARKING LOT AT WORK, AND 2 OF THE 3 BOLTS THAT HOLD THE STEERING COLUMN TO THE STEERING GEAR BOX BROKE, CAUSING LOSS OF STEERING TO THE RIGHT. THE STEERING WAS VERY LOOSE, AND I COULD EVENTUALLY TURN TO THE RIGHT, WHEN THE GEAR BOX LODGED AGAINST THE FRAME. I'VE NOTICED 3 OTHER INCIDENTS IN SEARCHING THIS WEBSITE. I THINK THIS IS AN AGE ISSUE WITH RANGER. BOLTS SHOULDN'T JUST BREAK IN TWO. I DIDN'T TAKE THIS TO A DEALERSHIP, BUT MY FRIEND IS A MECHANIC AND DID THE WORK FOR ME. HOWEVER, I'M CONCERNED ABOUT SAFETY, BECAUSE IF THIS HAPPENS ON A HIGHWAY, SERIOUS FATALITIES CAN OCCUR.*AK
Aug 05, 2003
+ 11 more complaints for this component
ELECTRICAL SYSTEM
16 complaints
I CAME OUTSIDE TO MY 1997 FORD RANGER XLT AND IT WAS ON FIRE UNDER THE HOOD AN IN THE CAB ALREADY. THEN IT EXPLODED! *TR
Jan 23, 2010
DT: CALLER HAD AN ENGINE FIRE. CALLER'S SON WAS DRIVING AND SMELLED SMOKE, PULLED OVER AND CALLED THE FIRE DEPARTMENT. THE SON SAID VEHICLE MADE A POPPING SOUND AND HE COULD NOT GET AWAY FROM IT FAST ENOUGH BEFORE IT EXPLODED. THIS HAPPENED WITHOUT WARNING. FIRE DEPARTMENT CAME AND THERE WAS A REPORT FILED. DEALER SAID SHE DID NOT MAINTAIN THE VEHICLE BUT THE CALLER STATED SHE MAINTAINED THE VEHICLE. DEALER SAID THIS BECAUSE SHE DID NOT TAKE IT TO A FORD DEALER TO HAVE IT MAINTAINED. THE MANUFACTURER OFFERED NO HELP. THE FIRE DEPARTMENT DID NOT KNOW HOW THE FIRE STARTED.*AK
Jul 07, 2005
1997 EXPEDITION SPONTANEOUSLY CAUGHT FIRE IN THE DRIVEWAY 45 MINUTES AFTER IT HAD BEEN DRIVEN. THE FIRE DEPARTMENT AND POLICE CAME AND PUT OUT WHAT WAS ALMOST A CATASTROPHIC HOUSE FIRE. THE TRUCK WAS A TOTAL LOSS. TO REPLACE IT WITH SOMETHING COMPARABLE WE BOUGHT A 99 EXPEDITION. WE WERE OUT $8000 IN THE TRADE. THE OLDER EXPEDITION HAD ONE CAR PAYMENT LEFT ON IT BEFORE THE FIRE. NOW I AM HORRIFIED THAT WE HAVE ANOTHER ON IN THE DRIVEWAY.*AK
Jan 28, 2005
VEHICLE STALLED WHILE DRIVING 20 MPH. VEHICLE WAS TOWED TO A REPAIR SHOP AND DIAGNOSED AS AN ELECTRICAL FAILURE. *AK
Jul 07, 2004
THE DASHBOARD LIGHTS AND DOME LIGHT BURNED OUT. THE DOOR AJAR WARNING CHIME SOUNDED FOR ABOUT FIVE MINUTES WHILE DRIVING, ALTHOUGH ALL THE DOORS WERE CLOSED. THE WIPERS CAME ON ALTHOUGH THEY WERE NOT TURNED ON. . *AK *NM
Feb 19, 2004
+ 11 more complaints for this component
ENGINE AND ENGINE COOLING
12 complaints
INCIDENT LIKE MANY OTHERS I HAVE HAD MY 1997 FORD EXPEDITION XLT BLOW A SPARK PLUG OUT OF THE CYLINDER HEAD. THE VEHICLE WAS RUNNING FINE AND TROUBLE FREE WHEN A POP FROM UNDER THE HOOD AND A LOUD BANGING NOISE CAME FROM THE ENGINE HEAD. THE VEHICLE WAS TOWED TO THE REPAIR SHOP ; WHO IN TURN CALLED THE LOCAL FORD DEALER. THE REPLY WAS THEY NEVER HEARD OF THIS PROBLEM BEFORE. MY LOCAL SERVICE TECH SAID THE REPAIR KIT ALONE WOULD COST $1,000,00. TO REPAIR IT HE SAID THAT FORD HAD ONLY USED 3 THREADS IN THE HEAD THAT FAILED, BUT ARE NOW REPLACING THEM WITH A 7 THREAD HEAD., THIS TELLS ME THAT THEY ARE VERY AWARE OF THE PROBLEM BUT ARE WILLING TO LEAVE THEIR CUSTOMERS OUT TO DRY.. I GUESS THE SCARY PART ABOUT THAT IS I STILL HAVE 4 MORE 3 THREAD SPARK PLUG HOLES TO WORRY ABOUT BLOWING OUT,.I ABSOLUTELY FEEL THIS SHOULD BE THE RESPONSIBILITY OF FORD MOTOR COMPANY WHO IS LOOKING FOR THE AMERICAN PUBLIC TO BUY IT'S TRUCKS. DAMAGE RESULTING IT WILL COST ME AS LITTLE AS $2,500.00 TO REPAIR THE CURRENT PROBLEM ( AND NO GUARANTY IT WON'T HAPPEN AGAIN). OR UP TO $5,500.00 TO REPLACE THE BUILT TOUGH 5.4 TRITON ENGINE. *TR
Jun 05, 2007
CONSUMER STATED WHEN STARTING VEHICLE IT IDLED AND WOULD NOT SLOW DOWN. ALSO, WHILE DRIVING VEHICLE SUDDENLY TOOK OFF WHILE STILL IDLING VERY HIGH. CONSUMER TOOK VEHICLE TO DEALER 3 TIMES, AND EACH TIME , THE VEHICLE WAS PUT ON THE DIAGNOSTIC MACHINE AND NOTHING WAS FOUND. CONSUMER WAS AFRAID OF AN ACCIDENT IF THIS CONTINUED. *AK
Sep 29, 2004
WHILE DRIVING FROM HOME TO WORK AT 40 MPH VEHICLE IMMEDIATELY DIED. VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, WHO STATED THAT ALL FOUR VALVES CRACKED AND ENGINE BLOCK BROKE. *AK
Oct 15, 2003
1997 FORD RANGER TRUCK-SHORTLY AFTER LEAVING MY HOME, WITHIN 10 MINUTES, I NOTICED A CLICKING NOISE. I THOUGHT IT WAS THE CAR NEXT TO ME, I LOOKED AT MY GAUGES AND NOTICED NOTHING UNUSUAL. WITHIN APPROXIMATELY 1 MINUTE THE CAR LOST POWER. I IMMEDIATELY PULLED TO THE SHOULDER AND TURNED THE CAR OFF. JUST BEFORE TURNING OFF THE IGNITION THE TEMPERATURE GAUGE SPIKED TO HOT. UPON EXAMINATION IT WAS DETERMINED THAT WITHOUT ANY WARNING THE ENGINE GOT HOT ENOUGH TO CRACK ALL FOUR VALVES IN THE ENGINE HEAD. BASICALLY A NEW ENGINE IN A CAR WITH 84,000 MILES ON IT. IT IS MY UNDERSTANDING THAT THIS ENGINE IS RATED TO LAST 200,000 MILES. *LA
Oct 15, 2003
97 FORD RANGER 4WD ~79K MILES, MY WIFE WAS DRIVING HOME FREOM WORK ON BACK ROAD DOING 30 MPH. SHE THOUGHT SHE RAN OVER SOMETHING AND THE TRUCK IMMEDIATELY DIED. NO ENGINE, POWER STEERING OR ANYTHING. *AK WHAT HAPPENED WAS THE CRAK SHAFT BROKE OFF AT THE ENGINE BLOCK. A WHOLE ENGINE REPLACEMENT WAS NEEDED. INSPECTING WHERE THE SHAFT BROKE OFF IT IS OBVIOUS TO ME, THE MECHANIC AND OTHERS THAT PART WAS DEFECTIVE IN THE MANUFACTURE PROCES. ABOUT 40% OF THE RING OF THE SHAFT LOOKS FINE (SOLID STEEL). THE REMAINDER OF THE RING IS ALL POUROUS. IT LOOKS LIKE A BAD FORGE PROCESS. ALTHOUGH THERE WAS NO DAMAGE OR INJURY OR WORSE, I DO BELIEVE THIS DEFECT PRESENTED A DANGEROUS SAFTEY ISSUE. IF THIS HAD HAPPENED ON THE HYWAY THE CONCEQUENCES COULD HAVE BEEN CATASTROPHIC. THE DEFECT SHOULD HAVE BEEN CAUGHT IN SOME QUALITY CONTROL PORCESS. I HAVE CONTACTED FORD ABOUT REIMBURSMENT FOR THE ENGINE REPLACEMENT BUT THEY WILL NOT CONSIDER IT. I HAVE THE PART THAT BROKE OFF AND CAN SUPPLY YOU WITH DIGITAL PHOTOS IF THAT WOULD HELP. THANK YOU FOR THIS OPPORTUNITY TO REGISTER THIS COMPLAINT.
Jun 03, 2003
+ 7 more complaints for this component
EQUIPMENT
10 complaints
I HAD AIR CONDITIONING INSTALLED AT THE TIME OF PURCHASE IN LATE 1997, THE AIR CONDITIONING WENT OUT LAST YEAR. SHOULDN'T IT LAST LONGER THAT 6 YEARS?*AK
Jul 27, 2004
FILED COMPLAINT BEFORE, YOU ALL SAID IT WASN'T SAFTY RELATED.IT SURE IS WHEN FORD MAKES PARTS OUT OF THIN PLASTIC/OR PUT IN WRONG PLEUM CHAMBER.THE BLEND DOOR WON'T OPERATE AND BREAKS ON SO MANY EXPLORER/RANGER.YOU CAN'T EVEN DEFROST YOUR WINDOWS IN THE RAIN OR IN THE MORNING.DO THEY HAVE TO WAIT FOR SOMEONE TO GET HURT/KILLED FOR SOMEONE TO CARE.
Dec 17, 2002
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
Apr 28, 2001
CARRIER THAT HOLDS SPARE TIRE RUBS AGANIST TIRE WHENEVER VEHICLE MOVES UP AND DOWN WHICH LEADS TO TIRE WEARING OUT. TIRE HAS NEVER BEEN USED BEFORE. CONTACTED DEALER AND THE DEALER IS NOT WILLING TO DO ANYTHING. *AK
Mar 23, 2001
HAD A RIGHT FRONT TIRE GO FLAT. WITH THE TIRE FLAT, THE VEHICLE JACK WOULD NOT FIT UNDER THE SHOCK ABSORBER AS THE OWNERS MANUAL DESCRIBES PROPER JACKING OF THE VEHICLE. I CONTACTED THE LOCAL FORD DEALER WHO SAID TO JUST MOVE THE JACK TO A NEARBY LOCATION. I DID THIS BUT WAS VERY UNEASY DOING SO AS IT DIDN'T SEEM ESPECIALLY SECURE AND I WAS WORRIED THE CAR COULD SLIP OFF THE JACK. ODD THAT WITH A FLAT TIRE, THE JACK IS TOO TALL TO PLACE IT WHERE THE MANUFACTURER RECOMMENDS.*AK
Mar 15, 2001
+ 5 more complaints for this component
SEAT BELTS
9 complaints
UNDER HARD BRAKING TO AVOID AN ACCIDENT THE SEAT BELT DISENGAGED FROM THE BUCKLE. I HAVE BEEN DEALING WITH THE SEAT BELT BUCKLE NOT "BUCKLING" WITH THE SEAT BELT FOR YEARS. LOOKING ONLINE I SEE NUMEROUS PEOPLE COMPLAINING OF THE SAME PROBLEM. COMPLAINTS OF A SPRING IS MISSING OR BROKEN, COINS ARE STUCK DOWN INSIDE THE MECHANISM, ETC. THIS IS A DEFECTIVE DESIGN! I CAN ONLY WONDER HOW MANY INJURIES OR DEATHS HAVE OCCURRED FROM SEAT BELT BUCKLE FAILURE. EVERY DAY I GET IN MY TRUCK I HAVE TO WIGGLE THE BELT BACK AND FORTH TO GET IT TO ENGAGE. SOMETIMES I JUST CHECK AFTER IT HAS ALREADY ENGAGED AND IT COMES LOOSE. THE DEALER SOLUTION IS TO PAY THEM FOR A "REPLACEMENT" ITEM, THE COST OF WHICH IS AROUND $250-300... I'LL BE PURCHASING A REPLACEMENT. THE ONLY PROBLEM IS THAT THE REPLACEMENT IS OF THE SAME DESIGN. I'M ASKING FOR HELP TO REMEDY A LIFE THREATENING SITUATION. *TR
Dec 28, 2012
WHILE ATTEMPTING TO BUCKLE SEAT BELT, BUCKLE LATCH DID NOT LOCK FIRMLY. FURTHER INVESTIGATION REVEALED THAT THE LATCH WOULD DISENGAGE WITH A LIGHT TUG. THERE APPEAR TO BE BROKEN PARTS OR FOREIGN OBJECTS IN THE MECHANISM PREVENTING PROPER FUNCTION. DUE TO THE MANNER OF CONSTRUCTION, THE ACTUAL CAUSE OF THE DEFECT IS NOT READILY VISIBLE. *TR
Aug 16, 2008
DT*: THE CONTACT STATED THE DRIVER'S SEAT BELT BUCKLE BECAME DISENGAGED ON A FREQUENT BASIS. THE CONTACT CHECKED FOR DEBRIS AND DIRT IN THE BUCKLE AND STATED THERE WAS NONE. THE SERVICE DEALER DETERMINED THE CONTACT WOULD NEED TO BUY A NEW SEAT BELT, WHICH WERE NOT AVAILABLE FOR PURCHASE. THE CONSUMER STATED THE PRESSURE SPRING ASSEMBLT BECOMES WEAK OVER A PERIOD OF TIME. UPDATED 12/28/06. *JB
Nov 29, 2006
WHILE DRIVING 45 MPH CONSUMER'S VEHICLE HIT ANOTHER VEHICLE . UPON IMPACT, BOTH SEATBELTS FAILED, RESULTING IN INJURIES; BROKEN RIB/ NECK INJURY, CUTS, AND BRUISES. DRIVER HIT STEERING WHEEL WHILE PASSENGER HIT WINDSHIELD. FRONT IMPACT, VEHICLE WAS TOTALLED.*AK
Sep 14, 2001
WHEN GOING OVER BUMPS SEAT BELTS UNLOCK, LEAVING OCCUPANTS UNRESTRAINED. DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE FURTHER INFORMATION.*AK
Sep 13, 2001
+ 4 more complaints for this component
SEATS
8 complaints
I WAS LEAVING THE PARKING LOT OF THE GROCERY STORE I HAD BEEN SHOPPING AT, AND THE DRIVERS SIDE RECLINING SEAT LATCH ASSEMBLY THAT CONTROLS THE ANGLE OF, AND LOCKS THE BACK OF THE SEAT INTO POSITION, GAVE WAY AND THE BACK OF THE SEAT COLLAPSED BACKWARDS CAUSING ME TO GO BACKWARDS AS WELL. FORTUNATELY I WAS ABLE TO STOP MY VEHICLE WITHOUT CAUSING A COLLISION OR INJURY. THE VEHICLE IS NOW AT HOME, AND WITH INTERNET RESEARCH IT SEEMS THAT THE RECLINING SEAT LATCH ASSEMBLY HAS BEEN A WEAK POINT WITH FORD RANGER TRUCKS AND FORD EXPLORER SUV VEHICLES FOR YEARS. THE FORD DEALER/SERVICE CENTER THAT I DO BUSINESS WITH, NOW TELLS ME THAT THE REPLACEMENT PART IS OBSOLETE AND THEY WILL HAVE TO CONTACT VARIOUS DEALERS STILL LISTING IT IN THEIR INVENTORY TO SEE IF THEY CAN GET THE PART, AS THE PARTS SUPPLIER FOR FORD THAT MADE THE REPLACEMENT LATCHES WENT OUT OF BUSINESS DURING THE BAD ECONOMY. I'M AMAZED THAT A RECALL HAS NOT BEEN ISSUED, GIVEN THE POTENTIAL FOR GREAT HARM AND POSSIBLE INJURY OR DEATH FROM THE FAILURE OF THIS COMPONENT.
Dec 30, 2010
DT: CONSUMER STATES WHILE DRIVING HIS VEHICLE, THE DRIVER'S SEAT COLLAPSED BACKWARD. *TT
May 27, 2005
SEATBELT LATCH WILL NOT HOLD SECURELY ON DRIVERS SIDE. CALLED ELYRIA FORD AND FORD CUSTOMER SERVICE, BUT WAS ADVISED THEY WOULD DO NOTHING UNLESS THEIR WAS A RECALL. UPON CHECKSING I SEE THAT OTHER FORD VEHICLES HAVE BEEN RECALLED FOR SEATBELT DEFECTS.*AK
Feb 05, 2002
MY FATHER WAS REAR-ENDED AT 55-65MPH. AS A RESULT OF THE ACCIDENT, MY FATHER'S SEAT BROKE CAUSING HIS SEAT TO FLY BACKWARDS AND THUS, HIS HEAD TO CRASHED THROUGH THE BACK WINDOW OF HIS PICKUP TRUCK. MY CONCERN IS THAT THIS SEAT SHOULD HAVE WITHSTOOD THIS KIND OF IMPACT. BECAUSE OF THE SEAT BREAKING, MY FATHER HAS SUSTAINED NUMEROUS LACERATIONS TO HIS FACE AND NECK, AND MASSIVE NECK INJURIES. MY FATHER'S INJURIES WOULD NOT HAVE BEEN SO SEVERE IF THE SEAT WITHSTOOD THE IMPACT. MY FATHER WAS WEARING HIS SEATBELT AT THE TIME OF THE ACCIDENT. CAN YOU PLEASE PROVIDE ME WITH A LIST OF INSTANCES WHICH A FORD RANGER'S SEAT HAS BROKEN IN THE PAST? ALSO, WHO IS THE MANUFACTURER OF THE SEAT IN THE FORD RANGER PICKUP TRUCK? IF YOU COULD INVESTIGATE THIS MATTER, I WOULD GREATLY APPRECIATE IT. MY FATHER WEIGHS APPROXIMATELY 180-190PDS AND IS 5'11" THANK YOU, [XXX]. *AK INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *JS *TR
Jan 03, 2002
A METAL PLATE/BAR WHICH HELPED TO SUPPORT HEAD RESTRAINT ON DRIVER'S SEAT WOULD HIT BACK OF DRIVER'S HEAD, AND COULD LEAD TO HEAD INJURY IF INVOLVED IN A CRASH. DEALER NOTIFIED, AND INFORMED CONSUMER THAT IT WAS A DESIGN FLAW. MANUFACTURER INFORMED THAT VEHICLE WAS OUT OF IS WARRANTY, AND UNWILLING TO ASSIST IN THIS MATTER. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
Oct 12, 2001
+ 3 more complaints for this component
FUEL/PROPULSION SYSTEM
6 complaints
LOOKED UNDER MY FORD RANGER AND SAW THAT BOTH OF THE METAL STRAPS THAT HOLD THE FUEL TANK TO THE VEHICLE HAD RUSTED THROUGH AND BROKEN IN HALF. I SAW THAT THERE WAS A RECALL FOR THE SAME ISSUES ON MY YEAR, BUT ONLY FOR THE FORD F150, NOT THE FORD RANGER, EVEN THOUGH THE ISSUE IS THE SAME.
May 09, 2015
PLASTIC FUEL LINE SPLIT AT THE INPUT OF THE FUEL FILTER THAT IS LOCATED BEHIND THE ENGINE ATTACHED TO THE VEHICLE FRAME. WHEN THE IGNITION IS TURNED ON GASOLINE SPRAYS FROM THIS CRACK PIECE OF PLASTIC LINE. THIS IS DUE TO THE FACT THAT THE FUEL PUMP IS ELECTRIC AND ENERGIZES ANYTIME THE IGNITION IS ON THE PUMP IS LOCATED IN THE GAS TANK AT THE REAR OF THE TRUCK . THIS IS POTENTIALLY VERY DANGEROUS AS THE SPRAYING GASOLINE COULD EASILY HIT THE CATALYTIC CONVERTER OR EXHAUST SYSTEM WHEN THE VEHICLE IS IN MOTION. FORTUNATELY I NOTICED THE LEAK UNDER THE VEHICLE WHEN I WAS WARMING UP THE CAR ON AS COOL MORNING. AS A RESULT NO REAL DAMAGE WAS DONE. WILL COST ABOUT $350 TO REPAIR. *TR
Dec 31, 2012
TL* THE CONTACT OWNS A 1997 FORD RANGER. THE CONTACT STATED THAT FUEL SPILLED FROM THE VEHICLE AND ONTO THE GROUND AS THE CONTACT ATTEMPTED TO REFUEL THE VEHICLE. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHOM LOCATED THE FAILURE AT THE FUEL FILTER NECK HOSE, WHICH WAS CRACKED DUE TO CORROSION. THE VEHICLE WAS REPAIRED AND THE FUEL FILTER NECK HOSE WAS REPLACED. THE MANUFACTURER DENIED ANY ASSISTANCE WITH THE REPAIR DUE TO THE VEHICLE'S AGE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000 AND THE APPROXIMATE CURRENT MILEAGE WAS 210,000.
Oct 02, 2012
NO INCIDENT OCCURRED BECAUSE I FOUND IT IN TIME (THANK GOD)! I CAME OUT MY FRONT DOOR AND NOTICED SOMETHING HANGING UNDER MY TRUCK. I TOOK IT TO CAR-X AND THEY TOLD ME IT WAS ONE OF MY SUPPORTS HOLDING UP MY GAS TANK. RIGHT THERE I ALMOST HAD A HEART ATTACK! I ASKED THEM TO CHECK IT OUT. THE NEXT DAY THEY CALLED ME AND TOLD ME THEY COULDN'T FIX IT BECAUSE IT WAS TOO RUSTY UNDERNEATH. THEY EVEN CALLED THE DEALER, I GOT IT FROM, AND THEY TOLD THEM THEY DIDN'T WANT ANYTHING TO DO WITH IT. RIGHT NOW I HAVE A RATCHET BELT HOLDING IT UP BUT I'M AFRAID IT WON'T LAST THROUGH A LOT OF RAIN AND SNOW. *TR
Jul 19, 2012
EACH TIME I FILL UP, THE GAS TANK OVERFLOWS, CREATING A HUGE SAFETY RISK OF EITHER A FIRE OR EXPLOSION. *TR
Jun 06, 2012
+ 1 more complaint for this component
EXTERIOR LIGHTING
6 complaints
ONGOING PROBLEMS WITH 1997 FORD RANGER. *PH *CB
Apr 09, 2004
AT INTERMITTENT TIMES FOR A VARRYING LENGTH OF TIME HEADLIGHTS WILL CUT OFF. DEALER CANNOT FIND THE PROBLEM AND PUTS THE TRUCK BACK ON THE ROAD. *AK
Feb 11, 2000
HEADLIGHT RELAY FAILED. NLM
Feb 01, 1999
CONSUMER HAS BEEN EXPERIENCING PROBLEMS WITH LEFT TURN SIGNAL. THE TURN SIGNAL LEVER IS TOO LOW. WHEN TURNING SIGNAL ON, DRIVER'S KNEE HITS UP AGAINST THE TURN SIGNAL AND TURNS IT OFF. IT COULD CAUSE AN ACCIDENT IF OTHER DRIVERS ARE UNAWARE OF THE CONSUMERS ACTIONS. THE MANUFACTURER HAS BEEN CONTACTED. *AK *ML
Jan 21, 1999
WHILE DRIVING AT NIGHTTHE HEADLIGHTS WOULD GO OUT. THERE WOULD BE NO WARNING. TOOK VEHICLE TO DEALER AT LEAST 4 DIFFERENT TIMES FOR HEADLIGHTS. PROBLEM COULD NOT BE LOCATED. *AK
Jan 14, 1999
+ 1 more complaint for this component
UNKNOWN OR OTHER
5 complaints
BELT SEPARATION ON 2 TIRES IN ONE MONTH TIME SPAN. FUSION TOURING 195 70R14 91T. THESE TIRES HAVE 8/32 TREAD REMAINING. FAILURES WERE FRONT RIGHT, THEN LEFT READ ONE MONTH LATER. CAUSED DIFFICULTY STEERING AS THE CAR WAS ALL OVER THE ROAD PLUS BUMPY RIDE. THE TIRES ARE VISIBLY BULGING BALOON. I FELT TIRE TEMP WITH MY HAND. UNIFORMLY WARM EXCEPT AT THE BULGE WHERE IT WAS SO HOT AS TO BURN MY HAND. WOULD NTSB LIKE ME TO SAVE A TIRE FOR EVALUATION? THIS SECOND TIRE FAILURE OCCURRED AT 70 MPH ON I-94 IN MICHIGAN WHEN A SUDDEN VIBRATION OCCURRED AND I OBSERVED THE LEFT REAR FENDER BOUNCING UP AND DOWN. I STOPPED TO INVESTIGATE AND FOUND THE BULGE AND HOT SPOT.
Nov 06, 2018
CONSUMER STATES THAT A COMPLAINT WAS MADE IN JUNE OF 2002 ABOUT A ROLLOVER ACCIDENT IN HER 1997 FORD RANGER AND WOULD LIKE AN INVESTIGATION OPEN. *NJ
Mar 20, 2009
ENGINE CHECK LIGHT KEEPS COMING ON. DEALER HAS GIVEN SEVERAL EXCUSES FOR THE WARNING LIGHT, AND STILL THER EIS NO SOLUTION. HAS BEEN IN 5 TIMES. *AK
Sep 13, 1999
WHILE SITTING AT A RED LIGHT ANOTHER VEHICLE HIT CONSUMER'S VEHICLE FROM REAR, CAUSING DRIVER'S SIDE AND PASSENGER'S SIDE SEATS TO BREAK AND FALL BACK ON THE CHILDREN WHO WERE SITTING IN THE REAR. *AK
Jul 20, 1999
CARGO COVER FAILED. *YC
Feb 01, 1999
VISIBILITY,INTERIOR LIGHTING
4 complaints
THE WINDSHIELD WIPERS CAME ON BY THEMSELVES AND THE WASHERS DID NOT WORK. ALSO THE DOME LIGHT STAYED ON AFTER THE DOOR WAS CLOSED FOR AT LEAST 30 MINUTES OR MORE. *JB THE WIPERS WOULD COME ON WHEN THE TURN SIGNALS WERE USED. THE DOME LIGHT WAS DISTRACTING AT NIGHT. SCC
Mar 05, 2003
WHILE DRIVING WINDSHIELD WIPERS TURN OFF AND ON WHENEVER THEY WANT TO. THEY SOMETIMES WILL NOT RUN AT ALL OR THEY WILL STOP RUNNING DURING USE. THE DOME LIGHT ALSO STAYS ON AND WILL NOT TURN OFF CAUSING A GLARE ON THE WINDOW. IT STARTED DOING IT WITH THE PASSENGER DOOR THEN THE DRIVER'S DOOR STARTED THE SAME PROBLEM. I CHECKED WITH A DEALER AND IT SEEMS TO HAVE BEEN A PROBLEM WITH RANGERS FOR MANY YEARS NOW AND STILL TROUBLES MANY OWNERS RIGHT UP TO THE 2001 MODELS. *MR *NLM *DIMSII IVOQ ENTRY POSTED AFTER 12/12/02 CUT-OVER TO ARTEMIS**739942
Jan 25, 2001
WINDSHIELD WIPERS CAME ON WITHOUT MANUAL OPERATION, AND WINDSHEILD WIPER FLUID RELEASED. CAUSE UNKNOWN. *AK DOOR AJAR LIGHT / DOME LIGHT REMAINED ON. *YH
Aug 22, 2000
WINDSHIELD WIPERS SEEM TO HAVE A MIND OF THEIR OWN. THE DOME LIGHT ALSO SEEMS TO HAVE A MIND OF IT'S OWN. THEY BOTH COME ON AND GO OFF WHEN THEY WANT TO. *AK
Apr 20, 2000
LATCHES/LOCKS/LINKAGES
3 complaints
HOOD LATCH AND SAFETY LATCH FAILED, CAUSING HOOD TO OPEN WHILE DRIVING. HOOD IS NOW DENTED FROM HOW FAR IT WENT BACK.
Sep 15, 2003
HOOD LATCH AND SAFTEY LATCH FAILED, WHICH RESULTED IN HOOD FLYING UP WHILE DRIVING.*AK
Mar 24, 2002
HOOD SUPPORT FAILED, CAUSING THE HOOD TO SLAM SHUT UNEXPECTEDLY AND WITHOUT ANY WARNING. COULD HAVE RESULTED IN INJURIES. *AK
Apr 07, 1998
SERVICE BRAKES, AIR
3 complaints
AFTER 17 THOUSAND MILES HAD TO REPAIR FRONT BRAKE CALIPERS.VEHICLE HAD REACHED 28 THOUSAND, AND HAD TO REPLACE FRONT CALIPERS. DEALER AND MANUFACTURER HAS BEEN NOTIFIED ; HOWEVER , WER UNABLE TO REMEDY THE PROBLEM.*AK
Jul 02, 2002
FRONT ANTI LOCK BRAKE FAILURE.
Sep 08, 1999
BRAKE FAILURE AT 50 MPH AND ABOVE.
Jan 06, 1998
SUSPENSION,STRUCTURE
2 complaints
FRAME IS NEARLY GONE / RUSTED , REAREND / AXLE FELL OUT IN MIDDLE OF ROAD. *TR
Mar 27, 2012
WHEN DRIVING MY RANGER IF I HIT A SMALL BUMP OR POTHOLE THE TRUCK BECOMES VERY DANGEROUS TO OPERATE. THE VEHICLE WANTS TO JUMP UNCONTROLLABLY FROM LANE TO LANE POSING DANGER TO MYSELF OR OTHER DRIVERS ON THE ROAD. RECENTLY I NOTICED A SMALL HAIRLINE CRACK IN THE ROOF OF THE CAB ABOVE THE DRIVERS SIDE AND THE FRONT PASSENGER PANEL PROTRUDES AWAY FROM THE VEHICLE. THIS TELLS ME SOMETHINGIS SERIOUSLY WRONG AND THE VEHICLE IS UNSAFE TO BE ON THE ROAD.NOT ONLY IS THE TRUCK A HAZARD BECAUSE OF THE UNSTABLENESS OF OPERATION NOW IT HAS A STRESS PROBLEM AS WELL AND IF IN AN ACCIDENT I WONDER IF THE THE STRUCTURE WOULD HOLD UP AS IT WAS DESIGNED TO DO. I HAVE SINCE PURCHASED ANOTHER VEHICLE AND BECAUSE OF THE SAFETY HAZARD AM REFRAINING FROM OPERATING THIS VEHICLE UNTIL A LATER DATE. I HOPE SOMETHING IS DONE BEFORE SOMEONE IS SERIOUSLY INJURED. *AK
Nov 19, 2001
POWER TRAIN,ELECTRICAL SYSTEM
2 complaints
NORMAL DRIVING, FAILURE OF THE ELECTRONIC FOUR WHEEL DRIVE SYSTEM, SYSTEM NOT YET REPLACED BECUASE OF LOW FUNDS. *AK
Jun 02, 2004
VEHICLE EXPERIENCED ELECTRICAL PROBLEMS WHICH WILL SHORT CIRCUIT. WHILE THE VEHICLE WAS AT THE DEALER, THE TRANSMISSION FELL OUT. PLEASE PROVIDE FURTHER INFORMATION. *AK
Dec 29, 1998
STRUCTURE,INTERIOR LIGHTING
2 complaints
WHEN SENSORS IN DOOR ACCUMLATE DIRT IT CAUSES DOME LIGHT TO COME ON. LIGHT WILL NOT GO OUT UNTIL CONSUMER TAKES OUT FUSE. CONTACTED DEALER, AND DEALER STATED IT WAS NOT COVERED UNDER WARRANTY. PLEASE PROVIDE VIN. *AK
Jun 26, 2001
THE DOME LIGHT WOULDN'T SHUT OFF AND CAUSED THE PINGING SOUND AS IF THE DOOR WAS AJAR. I CALLED CARRIAGE FORD (WHERE I BOUGHT THE VEHICLE). THEY SAID THE PROBLEM WAS NOT NECESSARILY IN THE DOME LIGHT BUT IN THE DOOR SWITCHES--THEY'VE HAD TO REPLACE A NUMBER OF THESE ALREADY. MY DAUGHTER, WHO LIVES IN TN, ALSO HAS A RANGER AND SHE'S HAVING THE SAME PROBLEM. I'VE NOTICED PEOPLE IN OTHER RANGERS DRIVING WITH THEIR DOME LIGHTS STUCK ON, TOO. I REASONED THIS MUST BE A COMMON PROBLEM AND CHECKED TO SEE HOW MUCH THE PARTS WERE TO REPLACE IT. I WAS TOLD IT WAS MINIMAL FOR THE PARTS--BUT THE LABOR WAS $160+. I CALLED CUSTOMER SERVICE AT FORD TO SEE IF THERE WERE ANY RECALLS WITH THESE PARTS. BECAUSE THIS IS PART OF THE SAFETY AND SECURITY FEATURES, (DOME LIGHT AS WELL AS REAR HIGH MOUNT BRAKE LIGHT) I HOPED THEY'D TAKE CARE OF IT. I WAS TOLD THEY WERE NOT ABLE TO HELP ME. CAN YOU? WHERE DO I GO FROM HERE? THANKS, [email protected]. *AK
Mar 05, 2001
ELECTRICAL SYSTEM,INTERIOR LIGHTING
2 complaints
ELECTRICAL SYSTEM MALFUNCTIONED. INTERIOR LIGHT STAYED ILLUMINATED WHILE VEHICLE WAS IN MOTION, DRAINING BATTERY.*AK
Feb 28, 2001
THE INTERIOR DOME LIGHT AND IGNITION ALARM WILL NOT STOP/TURN OFF WHEN VEHICLE IS TURNED OFF. THE IGNITION ALARM STOPS ONLY WHEN THE KEY IS REMOVED, THE DOME LIGHT STAYS ON FOR EXTREME EXTENDED PERIODS OF TIME. I HAVE HAD THIS REPAIRED ONCE IN 1998 OR 99. VEHICLE WAS UNDER WARRANTY. THE FORD MOTOR COMPANY REFUSES TO CORRECT THEIR DEFECT (12,000 MILE/12MO PERIOD IS UP) EVEN THOUGH IT IS RECURRING. THIS IS A SAFETY HAZARD. I CAN'T DRIVE AT NIGHT, BECAUSE I CANNOT SEE OUT OF MY WINDOWS.
Feb 20, 2000
SERVICE BRAKES, HYDRAULIC,TIRES
2 complaints
BRAKES AND TIRES WERE DEFECTIVE.. THE CONSUMER APPLIED BRAKES THE PEDAL WENT ALL TH E WAY TO THE FLOOR. ALSO, TWO FRONT TIRES BLEW OUT WHILE DRIVING ON THE HIGHWAY. *AK
Jan 20, 2000
BRAKES AND TIRES ARE DEFECTIVE. *AK
Jan 20, 2000
POWER TRAIN,VEHICLE SPEED CONTROL
2 complaints
CRUISE CONTROL IS ENGAGED,CLIMBING A SMALL RISE. ALSO, NEEDS TO SHIFT MANUALLY FROM 5TH TO 4TH GEAR. WHEN CLUTCH PEDAL IS DEPRESSED ENGINE WILL RACE TO A WIDE OPEN THROTTLE FOR SECOND ,AND THEN IT WILL COME BACK TO IDLE.DEALER CLAIMED CRUISE CONTROL WAS OPERATING AS DESIGNED. CRUISE CONTROL WILL NOT DEACTIVATE BY APPLYING CLUTCH PEDAL , ONLY BY APPLYING BRAKE PEDAL AND BUTTON. THIS IS IN CONFLICT WITH OWNER'S AND SERVICE MANUAL. *AK
Oct 14, 1999
WHILE TRAVLING ON THE HIGHWAY THE VEHICLE SHIFTS GEARS FROM 4TH TO 3RD. CONSUMER ALSO NOTICED THE RMP IDLES HIGH. PLEASE PROVIDE FURTHER DETAILS. *AK
Nov 13, 1997
PARKING BRAKE
2 complaints
EMERGENCY BRAKE HANDLE/CONTROL PULLED OUT AND WAS LOOSE ON SEVERAL OCCASIONS REQUIRED REPLACEMENT DUE TO THE SCREWS PULLING OUT FROM WEAK METAL. MJS
Jun 22, 1999
EMERGENCY BRAKE LIGHT FAILED. MJS
Jun 22, 1999
ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM
1 complaint
FORD RANGER 4X4 XLT 4.0L HAS HAD PROBLEMS FROM THE BEGINNING FRONT TIRES TWO OUT , FOG LIGHTS, AIR CONDITIONING, TRANSMISSION SHIFT POINTS , CHECK ENGINE LIGHT WHEN NEW AND TO THIS DAY GAS MILEAGE NOT AS STATED ON WINDOW STICKER ,ALSO WINDOWS MOTOR AND CONTROLS
Sep 23, 2020
EXTERIOR LIGHTING,ENGINE
1 complaint
THE DOME LIGHT STARTED TURNING ITSELF ON WHILE PARKED IN FRONT OF MY HOUSE. SOMETIMES IT WOULD TURN ITSELF BACK OFF. IT WOULD ALSO TURN ON WHILE I WAS DRIVING AT NIGHT. I COULDN'T GET THE LIGHT COVER OFF SO I PULLED THE FUSE WHICH LEAVES ME WITH NO WINDSHIELD WASHER SQUIRTER. THE CHECK ENGINE LIGHT IS ALWAYS ON. NO MATER WHAT IS DONE OR FIXED, THE LIGHT STAYS ON WHICH IS A PROBLEM BECAUSE CARS WILL USUALLY AUTOMATICALLY FAIL INSPECTION WHEN THE CHECK ENGINE LIGHT IS ON. HOW AM I SUPPOSED TO GET IT TO PASS INSPECTION IF ITS ON 90% OF THE TIME? I NEVER HAD A PROBLEM WITH MY 93 RANGER BUT OTHER PEOPLE WITH RANGERS HAVE HAD THE SAME ISSUES & THIS SITE SHOWS OTHERS WITH THE SAME ISSUES. WHY WON'T FORD RECALL & FIX IT WHEN ITS A KNOWN PROBLEM? THESE THINGS ARE SAFETY ISSUES!! I CAN'T ADD WHEN THESE THINGS HAPPEN BECAUSE THEY ARE ONGOING ISSUES FOR THE LAST TENISH YEARS!
Jun 14, 2017
VEHICLE SPEED CONTROL,SERVICE BRAKES,ENGINE
1 complaint
IDLE SPEED RISES TO 3,000 RPM IN BETWEEN SHIFTS AND WHILE COASTING WITH CLUTCH PEDAL DEPRESSED. DOES NOT DROP TO NORMAL IDLE SPEED UNTIL VEHICLE COMES TO A COMPLETE STOP. THIS CAUSES BRAKING TO BE LESS EFFECTIVE.
Jul 10, 2016
ELECTRICAL SYSTEM,EXTERIOR LIGHTING,INTERIOR LIGHTING
1 complaint
GUY NEXT DOOR KNOCKED ON MY DOOR LATE ONE NIGHT TO TELL ME THAT MY DOME LIGHT WAS ON. I LOOKED & IT WASN'T. HE SAID THAT WAS ODD BECAUSE HE EVEN WALKED BY IT & COULD SEE INSIDE. A FEW DAYS LATER IT HAPPENED AGAIN. THEN WHILE DRIVING AT NIGHT THE LIGHT CAME ON BY ITSELF. FROM THAT POINT ON IT WOULD RANDOMLY TURN ITSELF ON. NATURALLY FORD TOLD ME THAT WAS IMPOSSIBLE. THE ONLY WAY I COULD STOP IT WITHOUT PAYING A TON OF MONEY TO A GARAGE WAS TO PULL THE FUSE & I'VE HAD TO USE A FLASHLIGHT IF I NEED A LIGHT AT NIGHT EVER SINCE. MY TRUCK ALSO HAS A THEFT LIGHT BECAUSE A FACTORY ALARM WAS AN OPTION FOR MY TRUCK. I DO NOT HAVE AN ALARM BUT THE WORD ALARM IS STILL ON THE PANEL. THAT LIGHT WILL RANDOMLY TURN ON & SAY THEFT. I DO NOT HAVE AN ALARM! I TOLD FORD & THAT TOLD ME THAT WAS IMPOSSIBLE SINCE I DON'T HAVE AN ALARM. I SAID THAT MAYBE A WIRE WAS CROSSED SOMEWHERE BUT FORD TOLD ME," NO! ". TALKING TO OTHER RANGER OWNERS HERE & THERE I'VE FOUND OUT THAT NOT ONLY ARE THERE OTHERS DOING THE EXACT SAME THINGS BUT IT IS ALSO OTHER YEARS BESIDES 1997. I LIKE THE TRUCK JUST TIRED OF FORD & TIRED OF THE BS!!
Jul 28, 2015
AIR BAGS,SEAT BELTS,FUEL/PROPULSION SYSTEM
1 complaint
AIR BAGS.. DEFLATING, UNSERVICEABLE, DEMAND USELESS, ONLY ON PASSENGER SIDE, DRIVERS SIDE DISLODGED HORN FUEL/PROPULSION.. WITH FUEL TANK FILLED, FIRST HALF(1/2) TANK HAVING EXCESSIVE FUEL CONSUMED. SECOND (1/2) OF FUEL CONSUMED AT OWNERS MANUAL SPECIFICATIONS OF CITY AND HIGHWAY MILES PER GALLON. THROTTLE PEDAL STIFF, STICKS, AFTER NORMAL DAILY WARM UP, EXTRA FOOT PRESSURE NEEDED TO DISLODGE PEDAL AND CABLE, REAL SLUGGISH AS IF NOT RECEIVING ENOUGH FUEL TO INJECTORS, EVEN AFTER REGULAR MAINTENANCE COMPLETED.. SEAT BELTS.. DRIVERS SIDE HOOKUP RETAINING LATCH MALFUNCTIONS AND " WILL NOT REMAIN LATCHED", SEVERAL ATTEMPTS NEED TO BE MADE BEFORE GETTING A STRONG SEATBELT CLIP TO LATCH LOCKED ON
Jun 13, 2015
WHEELS,SERVICE BRAKES
1 complaint
WHEEL BEARINGS KEEP GOING OUT ON FRONT TIRES BECOMING A REAL ISSUE AND HAZARD AND SAFETY THEY LOCK UP ON ROAD AND HAVE GOTTEN SLIDES OFF ROAD. AFRAID IT WILL BE WORSE NEXT TIME. THEY HAVE GONE OUT THREE TIMES AND BEEN REPLACED. THEY ARE GOING OUT AGAIN AND FEAR FOR OUR SAFETY BUT THIS IS OUR ONLY VEHICLE FOR WORK AN APPOINTMENT NEED THIS TRUCK. PLEASE HELP. I DON'T HAVE THE MONEY TO KEEP REPLACING BUT LOVE THIS TRUCK. *TR
Feb 02, 2015
ENGINE
1 complaint
TL* THE CONTACT OWNS A 1997 FORD RANGER. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH, THE ENGINE STALLED. THE VEHICLE RESTARTED AFTER SEVERAL ATTEMPTS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING THE MECHANIC WAS UNABLE TO LOCATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.
Jul 28, 2014
STEERING,SUSPENSION,SERVICE BRAKES
1 complaint
REPORTING NUMEROUS SERIOUS SAFETY PROBLEMS WITH VEHICLE SINCE PURCHASED USED ---ORIGINAL OCCURRENCE DATE NOT CERTAIN BUT OVER A NUMBER OF YEARS MECHANICAL FAILURES OCCURRED THAT COULD HAVE RESULTED IN SERIOUS INJURY OR FATALITIES. THE FAILURES INCLUDE BUT NOT EXCLUSIVE TO ENTIRE BRAKE SYSTEM FAILURE DUE TO BRAKE LINES CORRODED AND LEAKED ALL HYDRAULIC FLUID --REAR BODY SUPPORT SYSTEM GAVE OUT DURING DRIVING AND REAR WHEELS AND AXLES NOT ATTACHED TO BODY ---VEHICLE LOST CONTROL AND WENT OFF INTO SHOULDER--RADIAL AXIAL ARM RUSTED AWAY AND STEERING SYSTEM FAILED WHILE DRIVING. GAS LEAKS FROM TOP OF TANK IF FILLED TO FULL --LEAKS ON TO GROUND AND COULD RESULT IN GAS FIRE AND EXPLOSION --DO NOT FILL TANK MORE THAN 3/4 ! ALL BRAKE LINES SHOULD BE REPLACED AND FREQUENT CHECKS OF STEERING AND SUSPENSION. I AM REPORTING THIS TO MAKE OWNERS AWARE AND TAKE PRECAUTION TO PREVENT INJURY OR DEATH.. *TR
Jul 18, 2014
ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM,EXTERIOR LIGHTING
1 complaint
ELECTRICAL PROBLEMS: 1. INTERMITTENT WIPERS WILL WIPE 2, 3, 4, 5 TIMES AT RANDOM IN A ROW ALWAYS AND NOT IN THAT ORDER. 2. BACKUP LIGHTS CONTINUE TO BLOW FUSE AFTER REPLACING ALL LIGHTING PARTS 3. HORN WORKS 1% OF THE TIME, UNABLE TO FIND CAUSE. 4. AC BLOWS HOT AIR INTERMITTENTLY EVEN AFTER REPLACEMENT OF BLOWER BLEND DOOR. 5. GAS: WHEN BELOW 1/4 TANK AND MAKING RIGHT TURN TRUCK WILL STALL, EVEN AFTER WORK ON TANK. *TR
May 10, 2010
ELECTRICAL SYSTEM,VISIBILITY
1 complaint
WITH ALL CONTROLS IN OFF POSITION, VERY HOT AIR STARTS COMING FROM FLOOR VENT (97 FORD RANGER) ALSO WHEN A/C IS TURNED ON,,HOT AIR COMES OUT. REPLACED SWITCH FOR HEAT/AIR CONTROL. *TR
May 01, 2010
SUSPENSION,SERVICE BRAKES, HYDRAULIC,FUEL SYSTEM, OTHER,TIRES,EQUIPMENT,TRACTION CONTROL SYSTEM
1 complaint
I OWN A 1997 FORD RANGER XLT 4X4 4.0LTR.MANY SHOPS HAVE WORK ON THE FRONT AXEL WHEEL BEARINGS AND SEALS AND RETAINER NUT THIS NUT TAKES A SOCKET 2.3/8 R-6 MOST SHOPS DON'T HAVE IT SO THEY USE WHAT EVER THEY HAVE,CHISELL,LOCKING PLYERS ECT...CREATING FRONT END DAMAGE TO WHEEL BEARINGS,SEALS, BRAKES,CALIPERS,BRAKE DRUMS, MOST OF AL THE TIRES..I HAVE SPENT THOUSANDS OF DOLLARS BECAUSE THEY DID NOT USE THE RIGHT TOOL FOR THE JOB ALSO DID NOT REMOVE LCKING PIN FROM SPINDEL. *TR
Apr 20, 2010
SERVICE BRAKES, HYDRAULIC,PARKING BRAKE
1 complaint
SUDDEN BRAKE FAILURE --TWO INSTANCES FIRST IN SEPT 2009 AND TODAY --SEVERE CORROSION ON REAR BRAKE LINES AND LOSE OF BRAKE FLUID AND NO BRAKES ---NEED TO CHECK ALL 1997 FORD RANGERS XLT FOR SIMILAR PROBLEMS AS CAN RESULT IN A CRASH. I HAVE HAD REPAIRS MADE AS AFRAID OF REPEAT ALSO NOTICE CORROSION AT FRONT BRAKE LINES. *TR
Nov 24, 2009
SERVICE BRAKES, ELECTRIC
1 complaint
DROVE MY 1997 FORD RANGER TRUCK TO LUNCH AT WORK UPON RETURNING SITTING DOWN FOR 10 MINUTES A COWORKER RAN INTO THE PLANT SAYING MY TRUCK WAS ON FIRE MY MASTER CYLINDER FOR MY BRAKES WAS ON FIRE AND WAS PUT OUT THERE IS ALOT OF DAMAGE. I BELIEVE WAS CAUSED BY DEFECTIVE ABS BREAK SENSOR DON'T KNOW IF THERE IS A RECALL ON THEM OR NOT HOPE YOU CAN HELP. *TR
Sep 19, 2009
ENGINE AND ENGINE COOLING,POWER TRAIN,SEATS
1 complaint
TL*THE CONTACT OWNS A 1997 FORD RANGER. WHILE DRIVING APPROXIMATELY 65 MPH ON NORMAL ROAD CONDITIONS, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE INDICATOR REMAINED LIT UNTIL THE ENGINE WAS TURNED OFF. WHEN THE SPEED WAS REDUCED, THE CONTACT HEARD A LOUD NOISE COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING, BUT THEY WERE UNABLE TO DUPLICATE THE FAILURE. ON A SEPARATE OCCASION, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO A TRANSMISSION SHOP FOR INSPECTION AND THE TRANSMISSION WAS RE-BUILT REPLACED. THE FAILURE MILEAGE WAS 59,099 AND THE CURRENT MILEAGE IS 126,431. UPDATED 05/08/09 *BF THE ENGINE LIGHT ILLUMINATED AND THE SEAT BROKE LOOSE. UPDATED 05/12/09.*JB UPDATED 06/09/09.*JB
Apr 14, 2009
FUEL SYSTEM, DIESEL
1 complaint
WHEN REFILLING GAS TANK, GAS SPILLS AND RUNS DOWN ALONG GAS TANK DURING LAST 1 GALLON OF FUEL. TO REMEDY THE PROBLEM, I STOPPED COMPLETELY FILLING UP THE GAS TANK. THIS PROBLEM BEGAN AFTER 8 YEARS OF USE AND ABOUT 100,000 MILES. *NM
Jul 06, 2006
ENGINE AND ENGINE COOLING,POWER TRAIN,TIRES
1 complaint
LTR FM EDWARD KURRELL (PA) RE FAULTY PARTS & POOR CRAFTSMANSHIP OF FORD VEHICLES, THE MOTOR IN HIS 1997 FORD RANGER BLEW UP DUE TO A FAULTY THERMOSTAT. *TS THE CONSUMER STATED HE NEEDED NEW TIRES AND THE 4-WHEEL DRIVE DID NOT WORK. *JB
Jan 19, 2006
FUEL SYSTEM, OTHER
1 complaint
1) THE VEHICLE IS A 1997 FORD RANGER XLT EXTENDED CAB PICKUP. A COUPLE OF YEARS AGO MY WIFE COMPLAINED ABOUT SMELLING GASOLINE WHEN SHE FILLED THE VEHICLE WITH GASOLINE. ON MORE THAN ONE OCCASION GASOLINE WAS OBSERVED DRIPPING FROM THE AREA UNDER THE FUEL TANK AFTER THE VEHICLE WAS FILLED WITH GASOLINE. THIS WOULD HAVE BEEN IN THE 2001-2002 TIME FRAME. *AK 2) IN LATE APRIL OF THIS YEAR 2004, THE CHECK ENGINE WARNING DASHBOARD WARNING LIGHT CAME ON, AND I HAD THE COMPUTER CODE CHECKED TO DETERMINE IF I COULD MAKE THE REPAIRS MYSELF. THE PROBLEM WAS THE FUEL FILTER, AND WHEN I REPLACED IT I NOTICED A GREAT DEAL OF DIRT AND DEBRIS COMING FROM THE INLET SIDE OF THE FILTER. THIS INDICATED TO ME THAT THE FUEL TANK WAS PROBABLY CONTAMINATED, AND I REMOVED THE TANK SATURDAY, MAY 15, TO CLEAN THE TANK. PRIOR TO REINSTALLING THE TANK, I EXAMINED THE GASOLINE FILLER TUBE, AND FOUND THREE CRACKS IN THE VAPOR RECOVERY TUBE THAT VENTS GASOLINE VAPORS TO THE FILLING STATION VAPOR RECOVERY SYSTEM. ONE OF THESE CRACKS WAS QUITE LARGE, AND SHOWED INDICATIONS OF GASOLINE LEAKING FROM THIS CRACK. NOT ONLY WAS THE CRACK THE SOURCE OF THE GASOLINE THAT LEAKED FROM THE SYSTEM, IT WAS ALSO THE ENTRY POINT FOR THE DEBRIS AND MOISTURE I FOUND IN THE TANK. IN ADDITION, THE GASOLINE THAT RAN FROM THE CRACK IN THE RECOVERY TUBE ACCUMULATED IN A PLASTIC SKID PLATE THAT IS LOCATED UNDER THE TANK. 3) I OF COURSE REPLACE THE TUBE ASSEMBLY, AT A COST OF $262.29. I CONTACTED FORD MOTOR COMPANY ABOUT THE PROBLEM AND FOR REIMBURSEMENT FOR THE REPLACEMENT PARTS. THEY DIDN'T SEEM TO BE THE LEAST BIT INTEREST IN THE PROBLEM AND REFUSED TO COMPENSATE THE EXPENSES. I HAVE RETAINED THE OLD PART, AND HAVE SEVERAL PHOTOS OF THE DEFECT.
May 23, 2004
SUSPENSION,ELECTRICAL SYSTEM,INTERIOR LIGHTING,EQUIPMENT
1 complaint
A FEW THINGS HERE, ENGINE LIGHT COMES ON AND GOES OFF AT RANDOM. HAD IT CHECKED A FEW TIMES. NO PROBLEMS FOUND. DOME LIGHT/DOOR CHIME WILL NOT GO OFF WHEN DOOR IS SHUT AND/OR CAR IS TURNED ON. LEFT HAND BLINKER WENT NUTS A FEW TIME, BASICLY IT WAS BLINKING AT A VERY HIGH RATE OF SPEED. A FEW SECOND 'POWER LOSS' HAPPEND A FEW TIMES WHILE DRIVING, LOST POWER TO RAIDO, AND LIGHTS. THE REAR END BOUNCES WAY TOO MUCH WHEN I HIT A BUMP, CAN CAUSE LOSS OF CONTROL AT HIGHWAY SPEEDS. *AK
Dec 26, 2003
FUEL SYSTEM, OTHER,ELECTRICAL SYSTEM,EQUIPMENT
1 complaint
THE LOCATION AND CONNECTION OF THE FACTORY ALARM SYSTEM CAUSED THE RELAY SWITCH UNDER THE DASH TO OVERHEAT AND THE BATTERY DRAINED EVEN WHEN THE VEHICLE WAS TURNED OFF.*JB ELECTRICAL SYSTEM ON 1997 FORD RANGER IS MALFUNCTIONING. ABS SYSTEM LIGHTS ILLUMINATES WHEN THE EMERGENCY BRAKE IS ENGAGED. THE FUEL GAUGE IS INOPERATIVE, RELAYS UNDER THE DASHBOARD STARTED HEATING UP. CONSUMER CONCERED THAT AIR BAGS MAY FAIL IF VEHICLE IS INVOLVED IN AN ACCIDENT.*MR
Dec 16, 2003
SERVICE BRAKES, HYDRAULIC,FUEL SYSTEM, GASOLINE,AIR BAGS
1 complaint
1997 FORD RANGER XLT EXTENDED CAB. WHEN I APPLIED MY BRAKES, INSTEAD OF STOPPING AT THIS "T" HWY INTERSECTION, I RAN PAST IT, AND HIT A 12" DIAMETER TREE HEAD ON. ICE ON THE ROAD. I WAS WEARING MY SEAT BELT. NEITHER THE DRIVER'S SIDE NOR THE PASSENGER SIDE AIR BAGS DEPLOYED. THE INDENTATION ON THE FRONT BUMPER WAS OVER TWO FEET DEEP. MY HEAD AND RIGHT SIDE OF MY BODY SMASHED AGAINST THE STEERING WHEEL, AND MY I BROKE MY LEFT COLLAR BONE, FRACTURED AND BRUISED SEVERAL RIBS ON MY RIGHT SIDE, BROKE MY RIGHT FOOT HEEL BONE, CUT MY NOSE, PLUS NUMEROUS OTHER MINOR CUTS, BRUISES AND ABRASIONS. AFTER ABOUT 45 SECONDS, A HUGE BALL OF FIRE ERUPTED FROM UNDER THE CRUMPLED HOOD. I FELT THE SUDDEN HEAT ON MY FACE, SINCE THE WINDSHIELD WAS GONE AND THERE WAS A HUGE GAP BETWEEN THE HOOD AND THE TRUCKS BODY. A LADY, AN ANGEL OF GOD REALLY, HELPED ME OUT OF THE TRUCK AND INTO THE BACK SEAT OF HER CAR. SHE DROVE ABOUT 100 YARDS TO WAIT FOR THE AMBULANCE TO ARRIVE. BEFORE WE CAME TO A STOP, I HEARD THE TWO FRONT TIRES OF MY TRUCK BLOW UP. ALL I COULD SEE WAS A BALL OF FIRE BURNING ABOUT 20 FEET HIGH. TWO THINGS SEEM TECHNICALLY WRONG: THE AIR BAGS DIDN'T DEPLOY, AND THE FUEL PUMP MUST HAVE KEPT PUMPING FUEL, FOR THE FIRE TO SPREAD SO RAPIDLY AND BURN THE FRONT OF THE TRUCK SO VERY COMPLETELY. THIS WOULD SEEM TO INDICATE THE POSSIBLE FAILURE OF THE AIR BAG CRASH SENSORS AND THE FUEL PUMP SAFETY CUTOFF SWITCH. MY TIRES WERE ONE MONTH OLD MICHELINS, SO THEY WEREN'T A FACTOR. THE TRUCK WAS IN EXCELLENT SHAPE AND IT WAS CAREFULLY MAINTAINED AND GARAGED. EVERYTHING WORKED ON IT AND NO MALFUNCTION INDICATOR LIGHTS OF ANY KIND WERE ON PRIOR TO THE ACCIDENT. I HAVE VERY GOOD MAINTENANCE RECORDS ON IT. I CONTACTED FORD BY TELEPHONE AND VIA E-MAIL, TO LET THEM KNOW OF WHAT I THOUGHT COULD BE A POTENTIAL COMPONENT DEFECT AFFECTING OTHERS ALSO. I ALSO CONTACTED THEIR LEGAL OFFICE VIA PHONE, AND THEY NEVER RETURNED MY CALL. *NLM
May 24, 2003
STEERING,STRUCTURE
1 complaint
BOLTS WHICH HOLD THE STEERING SECTOR TO THE FRAME ALL BROKE OR SNAPPED. I WAS LUCKY THAT I WAS SITTING IN A PARKING LOT AND STARTED TO TURNED THE STEERING WHEEL, THERE WAS A SNAP AND I WAS UNABLE TO TURN THE WHEELS OF THE TRUCK A 97 FORD RANGER. I SENT AN EMAIL TO FOR ON JANUARY 28, 2003 ABOUT THIS ITEM AND THEY HAVE NOT RESPONDED, THE TRACKING ID IS KMM2029449C0KM CASE ID 688902. I AM NORMALLY OUT ON THE HIGHWAY TRAVELING AT OVER 65 MPH ON WEEKEND AND HAD THE BOLTS SNAPPED WHILE MOVING AT THIS SPEED I WOULD PROBABLY BE DEAD. IS THERE ANY RECORDS OF THIS PROBLEM REPORTED BY ANYONE THAT IS STILL ALIVE? THANKS FOR YOU HELP. JUST WANTED T O INFORM YOU OF THIS HAPPENING. I HAVE NEVER HEARD OF THIS HAPPENING ON A VEHICLE. AS FAR AS I CAN DETERMINE THIS VEHICLE HAS NOT BEEN IN AN ACCIDENT. MOST OF THE 76,000 MILES HAS BEEN DRIVEN ON THE HIGHWAYS. THANKS AGAIN.
Feb 11, 2003
ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM,INTERIOR LIGHTING
1 complaint
ENGINE CHECK LIGHT WILL CONTINUOUSLY COME ON AND STAY ON. ALSO, ALARM WILL COME ON FROM TIME TO TIME, CAUSING VEHICLE TO SHUT OFF. CONTACTED DEALER WHO COULD NOT FIND CAUSE OF PROBLEM. *AK THE DOOR SWITCHES WILL NOT ALLOW THE INTERIOR LIGHT TO GO OFF UNTIL THE VEHICLE IS IN FULL MOTION WITH THE CLUTCH LET ALL THE WAY OUT. WHEN BACKING UP IN THE DARK IT IS HARD TO SEE OUT OF THE BACK WINDOW BECAUSE OF THE INTERIOR LIGHT BEING ILLUMINATED. *JG
Jul 01, 2002
STEERING,ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM,TRAILER HITCHES
1 complaint
AT THE SPEED OF 25MPH SUDDENLY HEARD A NOISE AND LOST TOTAL CONTROL OF STEERING WHEEL. MANAGED TO MERGE SUDDENLY TO RIGHT SIDE OF ROAD. BATTERY, ENGINE, AND POWER STEERING LIGHT WENT ON. WHILE LOOKING AT VEHICLE NOTICED THAT BELT BROKE AND DOLLEY FELL OFF. *AK
May 17, 2002
STEERING,EQUIPMENT ADAPTIVE/MOBILITY
1 complaint
I AM GETTING IN TOUCH WITH YOU TO LET YOU KNOW ABOUT A VERY SERIOUS PROBLEM WITH THE AFTER MARKET STEERING EXTENSION DEVICE PUT ON ALOT OF HANDICAPPED VEHICLES, THIS PART IS PUT ON THESE CARS AND TRUCKS TO HELP ASSIST THE DRIVER IN TURNING THE STEERING WHEEL . THE PROBLEM WITH THIS PART IS THAT IS NOT SAFE . WHEN THE STEERING WHEEL IS TAKEN OFF OF THE SPLINED SHAFT THE NEW PIECE IS PUT ON AND DOES NOT EVEN HAVE A SPLINED CENTER TO FIT TIGHT ON THE SHAFT AND THE ONLY OTHER THING TO HOLD IT TIGHT IS 2 SET SCREWS. IF ONE OF THESE SET SCREWS WOULD WORK LOSE OR IF THE STEERING WHEEL WERE TURNED TO HARD THESE SET SCREWS WOULD WORK LOOSE AND THE STEERING WHEEL WOULD TURN BUT THE WHEELS WOULDN'T , OR THE OTHER WAY AROUND . I HAVE TALKED TO A AUTO REPAIR SPECIALIST ALONG WITH THE HEAD MECHANIC SUPERVISOR AT A FORD DEALERSHIP AND BOTH MEN SAID THAT THIS PART IS NOT VERY SAFE AND THEY WOULD NT WANT IT ON THEIR CAR OR TRUCK , I ALSO TALKED TO THE PERSON WHO INSTALLED THIS PART HE NO LONGER USES THIS ALUMINUM PART BECAUSE IT IS NOT STRONG ENOUGH FOR THIS KIND OF STRESS THAT A STEERING WHEEL GOES THROUGH . I HOPE THAT YOU CAN MAKE THESE PARTS REPLACED BY THE COMPANIES SO THAT NO ONE WITH A MODIFIED HANDICAPPED STEERING COLUMN EXTENSION DOES NOT GET KILLED OR KILL SOMEONE ELSE , I WAS LUCKY TO FIND IT EARLY BUT MAYBE SOME ONE ELSE WON'T BE. THANK YOU SINCERELY [XXX]. *AK PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Feb 15, 2002
POWER TRAIN,INTERIOR LIGHTING
1 complaint
WON'T GO IN ANY GEAR THIS MORNING SEEMED FINE YESTERDAY.THE DOME LIGHT STAYS ON ALL THE TIME EVEN WITH THE DOOR CLOSED, IT HAS BEEN LIKE THIS FOR QUITE A WHILE AND IS VERY INCONVENIENT. *AK
Jan 25, 2002
SERVICE BRAKES, HYDRAULIC,POWER TRAIN,VISIBILITY,UNKNOWN OR OTHER
1 complaint
REAR BRAKES PULLED, SERVICED, REPORTED UNVERIFIABLE, BEGAN LOCKING UP IN SHORT BURSTS WHEN STOPPING, REPORTED, FOUND FAULTY , REPLACED COMPLETE REAR ASSEMBLY. WINDSHIELD CRACKED ACROSS CENTER WHILE DRIVING FREEWAY AT 65 MPH, STARTED AT TOP STRIP PASSENGER SIDE SPREADING ACROSS TO DRIVERS SIDE IN JUST MINUTES. DOOR AJAR SWITCHES FAILED CAUSING DOME LIGHT TO REMAIN ON MAKING NIGHT TIME VISIBILITY IMPOSIBLE. TRANSMISSION BEGAN SHIFTING ROUGH IN SECOND GEAR HARD TO DOWNSHIFT, VERIFIED, REPAIRED BEARINGS IN SHIFTER. REOCCURED A FEW MONTHS LATER, SERVICE CLAIMED UNVERIFIABLE, WORSENED STUCK IN FOURTH GEAR IN TRAFFIC, HAD TO BE PUSHED TO SHOULDER , AND DISENGAGED. FOUND TO BE FAULTY, AND TRANSMISSION WAS REBUILT ,NO NOTICABLE CORRECTION , RETURNED TO SERVICE, CLAIMED UNVERIFIABLE, CONTACTED FORD MOTOR COMPANY CORPORAT OFFICE, ADVISED TO GO TO DIFERENT DEALERSHIP , WHILE INVESTIGATED INTERNALLY. DID SO, DEALER REPORTS UNVERIFIABLE, DROVE WITH SUPERVISOR OF SERVICE DEPT, WAS THEN VERIFIED, AND ORDERED REBUILT FOR 2ND TIME.EPAIR, SAME TIME AS EXTENDED WARRANTY TOOK EFFECT, REPAIRS DONE, NO NOTICABLE DIFFERENCE, IN FACT NOW WORSE, ALL GEARS NOW EFFECTED.AND AT TIMES, DIFFICULT TO SHIFT. CONTACTED FORD MOTOR CORPORATION ONCE MORE, IN EFFORT TO GET HELP WITH EXTENSIVE RENTAL CAR COSTS WHILE VEHICLE BEING SERVICED, WAS TOLD NOW THAT TWO INCIDENCES WERE IN NO WAY RELATED NOW THAT EXTENDED WARRANTY WAS IN EFFECT TOO MUCH TIME PASSED, THOUGH EVEN ONLY LESS VTHAN 1000 MILES, IS STILL UNREPAIRED TODAY. *AK
Dec 27, 2001
FUEL SYSTEM, GASOLINE,UNKNOWN OR OTHER
1 complaint
CONSUMER WAS TRAVELING ABOUT 50MPH ON HIGHWAY, AND ENGINE CHECK LIGHT CAME ON. VEHICLE SHUT OFF WITHOUT PRIOR WARNING. CONSUMER HAD VEHICLE REPAIRED FOR A FUEL INJECTOR. *AK
May 31, 2001
WHEELS
1 complaint
A ROCK WAS CAUGHT BETWEEN TIRE AND RIM , CAUSING ALLOY RIM TO CRACK. DEALER / MSNUFACTURER WERE NOT NOTIFIED. RIM AVAILABLE FOR ANALYSIS. PLEASE FEEL FREE TO PROVIDE ANY FURTHER DETAILS ON THIS MATTER. *AK
Mar 28, 2001
STEERING,POWER TRAIN,EXTERIOR LIGHTING,VISIBILITY,STRUCTURE,SEATS,EQUIPMENT
1 complaint
POWER STEERING HAD TO BE REPLACED, WAS MAKING A NOISE LIKE PUMP WAS NOT WORKING PROPERLY. AIR CONDITIONER PUMP REPLACED. RIGHT WINDOW IS LOOSE WHILE GOING DOWN. TRANSMISSION SLIPS OCCASIONALLY WHILE TAKING OFF. THERE ARE LOOSE BOLTS UNDERNEATH SEATS. FOG LIGHT FAILED. CONSUMER STATES OIL FROM MASTER CYLINDER DAMAGED HOOD. DOOR LOCK INSIDE DRIVER'S DOOR NEVER WORKED AND WAS REPLACED. *AK *SLC
Mar 06, 2001
EXTERIOR LIGHTING,VISIBILITY,INTERIOR LIGHTING
1 complaint
WOULD BE DRIVING VEHICLE WHEN DOME LIGHT AND WINDSHIELD WIPERS COME ON BY THEMSELVES. HAVE TAKEN TO DEALERSHIP & MECHANIC INDICATED A POSSIBLE SHORT IN SWITCH WAS CAUSING PROBLEM. *AK
Feb 02, 2001
POWER TRAIN,EXTERIOR LIGHTING,VISIBILITY,INTERIOR LIGHTING
1 complaint
DOME LIGHT STAYS ON AFTER STARTED AND DOOR CLOSED AND DOES NOT GO OFF. PROBLEM SEEING AT NIGHT... NO WAY TO TURN OFF WITHOUT REMOVING THE BULBS. WINDSHIELD WIPERS DO NOT START WHEN TURNED ON THE DO NOT GO OFF WHEN SWITCHED OFF. HAVE TO TURN THE WIPERS ON THEN OFF AGAIN. SHIFT KNOB COMES OFF WHEN PULLING SHIFT LEVER FROM 1ST TO 2ND AND 3RD TO 4TH. MAKES SHIFTING DIFFICULT WHILE STARTING UP A HILL AND MERGING ON THE FREEWAY BECAUSE THE KNOB SLIPS OFF COMPLETELY AND THE SHIFTER ENDS UP IN THE NEUTRAL POSITION. *AK
Dec 30, 2000
STRUCTURE,LATCHES/LOCKS/LINKAGES
1 complaint
CONSUMER'S 2-YEAR OLD SON IS ABLE TO OPEN PASSENGER'S DOOR WHILE VEHICLE IS IN MOTION. VEHICLE WAS NOT MADE WITH THE CHILD PROOF LOCK. CONSUMER HAS NO WHERE ELSE TO PLACE HIS CHILD BECAUSE EXTENDED CAB IS NOT FITTED FOR CHILD SAFETY SEATS. DOORS THAT CAN BE OPENED WITH ONLY A PULL TO THE HANDLE CAN CAUSE SERIOUS INJURIES TO PASSENGER. *AK
Aug 14, 2000
VISIBILITY,STRUCTURE
1 complaint
DOOR SWITCHES AND WINDSHIELDWIPER SWITCH REPEATEDLY FAILED. SAME IN FATHER'S 1997 F150. *AK
Apr 11, 2000
SERVICE BRAKES, HYDRAULIC,VISIBILITY,SEATS
1 complaint
BRAKES LOCK UP AND TRUCK WILL SKID NO MATTER WHAT SPEED, TRUCK BECOMES UNCONTROLLABLE. WINDSHIELD WIPERS WILL COME ON AND SPRAY DURING SOME LEFT TURNS, FOR NO APPARANT REASON. THIS CAUSES THE INABILITY TO SEE. WHEN BRAKES ARE APPLIED(AND TRUCK GOES NUTS)THE PASSENGER FRONT SEAT LAUNCHES FORWARD EVEN THOUGH IT IS LOCKED INTO POSITION. ONE INCIDENT WAS I WAS MAKING A LEFT TURN ONTO A BUSY STREET WHEN MY WIPERS CAME ON AND SPRAYED FLUID ALL OVER, I TRIED TO APPLY MY BRAKES AND THE TIRES LOCKED UP AND TRUCK STARTED TO SKID, AND THE SEAT HOLDING MY INFANT SON'S CAR SEAT WAS THROWN FORWARD INTO THE DASH. I WAS TRAVELING MAYBE 4-6 MPH. SOME ONE IS GOING TO GET KILLED IN THIS VEHICLE. I CONTACTED FORD AND THEY SAY I HAVE NO RECOURSE AND HAVE NEVER HEARD OF SUCH THINGS HAPPENING WITH THIER VEHICLES. I HAVE HAD THE BRAKES INSPECTED AND I AM TOLD THAT THEY LOOK FINE, AND THERE IS NO PROBLEM WITH THE ABS DUMMY LIGHT COMING ON IN THE VEHICLE. PLEASE, PLEASE CAN YOU MAKE FORD DO SOMETHING ABOUT THIS? I NOTICED THAT THERE ARE A LOT OF SIMILAR COMPLAINTS WITH THIS TRUCK POSTED HERE ON NHTSA'S SITE. THANK YOU. *AK
Apr 07, 2000
EXTERIOR LIGHTING,INTERIOR LIGHTING
1 complaint
THE DOME LIGHT STAYS ON AT ALL TIMES WHICH MAKES IT DIFFICULT TO DRIVE AT NIGHT. ALSO, SOMETIMES THE THIRD BRAKE LIGHT WORKS AND SOMETIMES IT WILL NOT. TRUCK WAS TAKEN TO THE DEALERSHIP. DEALER COULD NOT FIND A PROBLEM WITH THE TRUCK. OWNER WAS SHOWN HOW TO REMOVE THE FUSE IF THE PROBLEM HAPPENED AGAIN. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK
Feb 24, 2000
STEERING,SUSPENSION
1 complaint
DRY SPINDLES AND BALL JOINT BEARINGS, MECHANIC PUT PICKUP ON JACK SAID " WE WRE LUCKY WE DIDNT WRECK" TIRE LEANED OUTWARD , EVENTULAY WOULD HAVE FALLEN OFF. *AK--
Jan 24, 2000
POWER TRAIN,EXTERIOR LIGHTING,VEHICLE SPEED CONTROL,EQUIPMENT
1 complaint
NO SUMMARY
Sep 22, 1999
SERVICE BRAKES, HYDRAULIC,WHEELS
1 complaint
WHILE DRIVING 40 MPH FRONT WHEEL ON THE PASSENGER'S SIDE SPLIT IN HALF, CAUSING COMPLETE FAILURE OF FRONT BRAKES.. OWNER WAS ABLE TO DRIVE TRUCK HOME SAFELY. DEALER WILL BE CONTACTED. PLEASE PROVIDE FURTHER DETAILS. *AK
May 14, 1999
SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING,POWER TRAIN,UNKNOWN OR OTHER
1 complaint
SELLING DEALER NOTIFIED EACH TIME, SOME REPAIRS MADE, PROBLEM NOT SOLVED. *AK
Mar 29, 1999
POWER TRAIN,VISIBILITY,UNKNOWN OR OTHER
1 complaint
NO SUMMARY PROVIDED BY THE CONSUMER( DOT NUMBER: TIRE SIZE: P225/75R14 )
Nov 14, 1998
ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL
1 complaint
GAS PEDAL FELL OFF, LEAVING CONSUMER STRANDED. COMPUTER PROGRAM IS CAUSING THE VEHICLE TO SURGE. DEALER HAD TO REPROGRAM COMPUTER. *AK
Oct 14, 1998
ENGINE AND ENGINE COOLING,VISIBILITY
1 complaint
VENTILATION SYSTEM DRAWS EXHAUST FUMES INTO PASSENGER COMPARTMENT.
May 26, 1998
STEERING,ELECTRICAL SYSTEM,VISIBILITY
1 complaint
WINDSHIELD WIPER COME ON ALL BY ITSELF. SOMETIMES IT WILL NOT TURN OFF, COMES ON A HIGH SPEED, SOMETIMES WASHER COMES ON ALSO, INCIDENTS OCCUR WHEN THE CONSUMER IS DRIVING. PROCESS DEVELOPED WHERE THE TILT STEERING CANNOT BE ADJUSTED OR MOVED EXCEPT WHEN THE ENGINE IS TURNED COMPLETELY OFF, CONSUMER STATES THAT THE VEHICLE HAS HAD A N ELECTRICAL SHORT. DEALER HAS NOT YET BEEN CONTACTED TO EVALUATE THE PROBLEM. *AK
May 05, 1998
POWER TRAIN,VISIBILITY,INTERIOR LIGHTING
1 complaint
THE SPEEDOMETER/ THE INTERIOR LAMP, AND THE WINDSHIELD WIPERS DON'T WORK. DEALER CAN'T FIND THE VEHICLE. *AK
Feb 05, 1998
AIR BAGS,SEATS
1 complaint
VEHICLE WAS STOPPED AND REARENDED BY ANOTHER VEHICLE, DRIVER'S SEAT WENT BACKWARDS, HIT DAUGHTER, KNOCKED HER FACE INTO BACK WINDOW; PASSENGER'S SEAT BROKE &PASSENGER WAS SWUNG INTO BACK WINDOW; SEATS STUCK IN RECLINING POSITION. ALSO, NO DEPLOYMENT OF DRIVER'S AIR BAG. *AK
Apr 01, 1997
Frequently Asked Questions
How many problems does the 1997 FORD Ranger have?
The 1997 FORD Ranger currently has 453 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.
What are the most common problems with 1997 FORD Ranger?
The most common problems reported for the 1997 FORD Ranger are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.
Where does this 1997 FORD Ranger problem data come from?
All problem and complaint data for the 1997 FORD Ranger comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.
Other Years - FORD Ranger
2025 Problems
2024 Problems
2023 Problems
2022 Problems
2021 Problems
2020 Problems
2019 Problems
2018 Problems
2017 Problems
2016 Problems
2015 Problems
2014 Problems
2013 Problems
2012 Problems
2011 Problems
2010 Problems
2009 Problems
2008 Problems
2007 Problems
2006 Problems
2005 Problems
2004 Problems
2003 Problems
2002 Problems
2001 Problems
2000 Problems
1999 Problems
1998 Problems
1996 Problems
1995 Problems
1994 Problems
1993 Problems
1992 Problems
1991 Problems
1990 Problems
Other FORD Models
'34
1500 Foldaway
A8513
A9513
A9522
Aerostar
Affordable Aluminum
Affordable Trailers
Aspire
AT8513
AT9513
AT9522
Similar Brands
ST
3,555 models
RS
3,484 models
NC
2,822 models
ND
2,385 models
Z
1,951 models
MOTO
1,583 models
NU
1,189 models
RC
1,122 models