How many problems does the 2005 FORD Ranger have?

The 2005 FORD Ranger currently has 289 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2005 FORD Ranger?

The most common problems reported for the 2005 FORD Ranger are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2005 FORD Ranger problem data come from?

All problem and complaint data for the 2005 FORD Ranger comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.

2005 FORD Ranger Problems

AIR BAGS

128 complaints

The contact owned a 2005 Ford Ranger. The contact stated while driving at 50 MPH, the vehicle was rear-ended by a driver who ran the stop sign. The impact caused the vehicle to flip over multiple times. The air bags failed to deploy. The contact suffered severe head trauma and PTSD from the accident. It was unknown if the other driver sustained any injuries. The contact was taken to the local hospital where medical attention was received for his injuries. A police report was filed. The vehicle was towed to a local salvage junkyard. The VIN was included in NHTSA Campaign Number 23V306000 (Air Bags). The local dealer was not contacted. The manufacturer was not notified of the failure. The failure mileage was approximately 130,000. The VIN was not available.

May 29, 2024

Crash: 1

Injuries: 1

See attached document for complaint

Apr 29, 2024

The contact owns a 2005 Ford Ranger. The contact had taken the vehicle to be repaired under NHTSA Campaign Number: 23V125000 (Air Bags). The contact stated that while the vehicle was having the air bag replaced, the contact became aware that the passenger’s side air bag had not been seated correctly. The contact asked the Service Manager to return the vehicle to have the mechanic properly seat the air bag and secure the air bag correctly. The contact stated that the Service Manager attempted to adjust and tighten the air bag. The contact stated that the vehicle had been repaired but not in a safe manner. The manufacturer had been informed of the issue. The failure mileage was approximately 228,000.

Oct 24, 2023

The contact owned a 2005 Ford Ranger. The contact stated while driving approximately 10 MPH, the vehicle struck the rear of another vehicle causing a fender bender. The contact stated that the front air bags deployed, and a powdery substance and metal fragments flew out of the air bag and landed on the contact. No injuries were sustained. No medical attention was required. A police report was filed. The vehicle was towed to an independent mechanic and deemed a total loss. The contact stated that he then received notification of the NHTSA Campaign Number: 17V880000 (Air Bags). An unnamed dealer and the manufacturer were notified of the failure and the contact was advised to call the NHTSA Hotline. The failure mileage was approximately 205,000.

Jun 12, 2023

Crash: 1

I was in an accident and the airbags did not inflate. I was going 30-35 MPH, there was a patch of ice, and I hit a tree. The truck was totaled. I smashed my face on the steering wheel, fracturing a bone. Some weeks later I received a letter in the mail from Ford Motor Company with regards to a passenger side airbag recall. I am afraid that this could perhaps be a bigger problem than just passenger side airbags.

Apr 12, 2023

Crash: 1

Injuries: 1

+ 123 more complaints for this component

FUEL SYSTEM, GASOLINE

21 complaints

FIRST TIME WE WERE SHOPPING, WHEN WE STARTED THE CAR IT WOULDN'T START. WE REPLACED THE FUEL PUMP? WHEN IT HAPPEN THE NEXT TIME WE WERE DRIVING WHEN ENGINE SHUT OFF,WE WERE ON A DIRT ROAD HAD NO POWER STEERING,NO POWER BRAKES ONLY GOING 20 MPH.THE SHOP TOLD US THAT IT WAS THE FUEL SHUTOFF VALVE IN CASE OF A CRASH. I PURCHASED THE RANGER 5/30/13 FROM A FORD DEALER.OVER THE PAST YEAR THE ENGINE HAS STOPPED 8 TO 10 TIMES.WE ON A WENT TRIP LAST WEEKEND IT HAPPEN TWO TIMES ON I 84 IN IDAHO WE WERE GOING 75 MPH. I DID GET THE TRUCK OFF THE FREEWAY BUT WONDER WHAT IF WE WERE IN BOISE OR SALT LAKE WITH ALL OF THE TRAFFIC WHAT MITE HAVE HAPPEN.HAS THIS HAPPEN TO OTHER RANGERS ????? *TR

Jun 05, 2014

TL* THE CONTACT OWNS A 2005 FORD RANGER EDGE. THE CONTACT WAS DRIVING 35 MPH WHEN THE VEHICLE STALLED. THE CONTACT STATED THAT THE STALLING WAS CAUSED BY THE RESET BUTTON BECOMING TOO HOT AND STOPPING THE FUEL FLOW TO THE ENGINE. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE FUEL PUMP WAS FAULTY. THE DEALER REPLACED THE FUEL PUMP BUT THE REPAIR DID NOT REMEDY THE ISSUE. THE CONTACT TOOK THE VEHICLE BACK TO THE DEALER AND THE DEALER REPLACED THE SECOND FUEL PUMP BUT TO NO AVAIL. THE FAILURE PERSISTED AND THERE WERE NO FURTHER REPAIRS. THE FAILURE MILEAGE WAS 77,000.

Jun 03, 2011

FUEL INERTIA SWITCH MALFUNCTION, SWITCH SHORTED OUT AND CAUGHT FIRE. THE INERTIA SWITCH WOULD TRIGGER AND SHUT OFF THE FUEL SUPPLY TO THE TRUCK, THIS HAPPENED ABOUT 25TIMES SINCE PURCHASING THE VEHICLE NEW, THE LAST TIME IT HAPPENED I WAS SITTING STILL IN BUMPER TO BUMPER TRAFFIC AND IT JUST SHUT OFF. I REACHED UNDER THE PASSENGER SIDE OF THE DASH BOARD TO RESET IT AND COULD FEEL THE HEAT FROM THE ELECTRICAL FIRE. I QUICKLY SHUT OFF THE VEHICLE AND THE FIRE DIED OUT. THE SAFETY SWITCH IS TOTALLY FRIED. *TR

Feb 02, 2011

Fire: 1

TL* THE CONTACT OWNS A 2005 FORD RANGER. THE CONTACT WAS DRIVING 55 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE FUEL CUTOFF SWITCH CONTINUOUSLY CAUSED THE VEHICLE TO STALL WITHOUT WARNING. THE CONTACT WAS ABLE TO RESET THE SWITCH AND RESUME DRIVING. THE DEALER WAS CONTACTED BUT PROVIDED NO ASSISTANCE. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THERE WERE NO RECALLS FOR THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 138,000.

Dec 07, 2010

THE TRUCK WOULD SUDDENLY STOP RUNNING. IT OCCURRED RANDOMLY, SOMETIMES WEEKLY, SOMETIMES MONTHLY, I NEVER KNEW WHEN IT WOULD HAPPEN. IT WOULD EVENTUALLY RESTART. AFTER REPLACING THE FUEL FILTER AND THE FUEL PUMP (TWICE) TO NO AVAIL, I ASKED MY NEIGHBOR TO LOOK AT THE INERTIA SWITCH (FORD WOULD NOT; THEY SAID THAT "COULDN'T BE THE PROBLEM"). THE SWITCH WAS ALL FRIED OUT INSIDE, AND THE CONNECTOR AND THE WIRE LEADING TO IT WERE MELTED. APPARENTLY, THE CONNECTOR WAS BAD. HE SAID THAT IT SHOULD HAVE CAUGHT FIRE ALREADY. HE REPLACED THE SWITCH AND PUT IN A DIFFERENT CONNECTOR AND I'VE HAD NO FURTHER PROBLEMS. I CAN'T BELIEVE THAT I NEVER HAD AN ACCIDENT, AS I MOSTLY DRIVE ON THE FREEWAY AND IN THE MOUNTAINS. *TR

May 21, 2010

+ 16 more complaints for this component

STRUCTURE

19 complaints

THE REAR PORTION OF THE FRAME IS RUSTING AWAY AND THE LEAF SPRING SHACKLE FELL OFF WHILE DRIVING ON A CITY STREET CAUSING THE BED OF THE TRUCK TO FALL ONTO THE BUSTED SHACKLE. THE SPARE TIRE MOUNT IS RUSTED SO BAD THAT WE REMOVED THE SPARE TIRE TO AVOID LOOSING THE SPARE WHILE DRIVING. THE REAR BUMPER SEEMS UNSTABLE AS THE FRAME IS RUSTED AND FALLING APART FROM THE REAR SHACKLE MOUNT ON BACK. THE FRONT PORTION OF THE FRAME SEEMS TO BE HOLDING UP OK.

Aug 05, 2020

TL* THE CONTACT OWNS A 2005 FORD RANGER. THE CONTACT STATED WHILE DOING A ROUTINE CHECK UNDER THE VEHICLE, THE CONTACT NOTICED THAT THE SUBFRAME UNDER THE VEHICLE WAS SEVERELY RUSTED. THE VEHICLE WAS NOT TAKEN TO BE INSPECTED BY AN AUTHORIZED DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 55,000.

Jul 22, 2020

TRUCK IS IN GOOD SHAPE W/123,600 MILES. FRAME ROTTED THROUGH AT REAR AXLE. SPARE TIRE AND HOLDER DROPPED RIGHT OUT OF IT AND WAS HANGING BY A THREAD. I WAS ABLE TO GET IT TO SHOP AND CUT SPARE TIRE AND HOLDER COMPLETELY OFF. *TR

May 14, 2020

THE FRAME IS BADLY RUSTED, ESPECIALLY IN THE REAR. THE DRIVER SIDE REAR LEAF SPRING SHACKLE FELL OFF ABOUT 12 MONTHS AGO. WITHING THE LAST WEEK , THE REAR BUMPER BECAME DETACHED ON THE DRIVER SIDE. THE PASSENGER SIDE IS NOT FAR BEHIND EITHER. THE LEAF SPRING SHACKLE PROBABLY HAPPENED WHILE DRIVING, BUT DID NOT SIGNIFICANTLY AFFECT VEHICLE PERFORMANCE. THE REAR BUMPER FELL OFF WHILE THE VEHICLE WAS STATIONARY.

Jul 09, 2019

WELL JUST BOUGHT MY 2005 RANGER ONLY HAS 111,230 MILES AND HAS BEEN TAKEN CARE OF BODY LOOKS GREAT NO RUST AT ALL WELL THE FRAME IS TOTAL JUNK ROTTED BEYOND REPAIR EVEN WORSE THEM MY SEQUOIA I HAD SUPER DANGEROUS SO I STARTED DOING RESEARCH AND SEEMS LIKE A LOT OF PEOPLE HAVE SAME ISSUES I RUN A REPAIR SHOP AND I SEE 1/2 RANGERS A MONTH THAT ARE JUNK NOT JUST SPRING SHACKLES OR HANGERS COMPETE FRAMES I DON'T UNDER STAND HOW A TRUCK THAT THE BODY IS SUPER CLEAN NEVER PAINTED LOOKS FLAWLESS BUT FRAME BROKE FROM ROT FORD SHOULD HAVE TO REPAIR THESE JUNK FRAMES I HAVE VEHICLE IN MY BACK LOT I MAY TALK TO A LAWYER ONLY REASON I FOUND ISSUES IT WAS DUE FOR INSPECTION SUPER MAD DROVE IT WITH MY SON AND COULD HAVE BEEN SERIOUSLY HURT BECAUSE JUNK METAL

May 14, 2019

+ 14 more complaints for this component

UNKNOWN OR OTHER

10 complaints

My daughter called me screaming when her 2005 Ford Ranger FX4 Level 2 had unexplained runaway throttle while driving back to college in January 2022. The vehicle had the cruise control on for a couple hours and without warning, began to accelerate to the point that it was at the rev limiter, traveling at 90 miles an hour. She called me hysterical and I advised her to shut off the cruise and hit the brakes but nothing would stop her or turn off the cruise. I advised her to turn off the vehicle to ACC position and coast to the shoulder. When she had calmed down, I asked her to restart the truck, it started wide open throttle, so she immediately shut it off. I told my daughter then to mash the gas pedal a few times and restart the vehicle. It restarted at normal idle speed. 1/28/2022- my daughter came home from school today for a visit, the same thing happened again on her drive home. She was able to coast to the shoulder and restart after mashing the pedal a few times. I am advising her not to use the cruise control and to get it into a Ford shop to inspect. There are no lamps or warnings to indicate there is an issue or code/CEL. This is a deadly situation that apparently has occurred with Ford Explorers that have the 4.0 Liter engine and 5.0L engine. It appears from other forums (https://www.explorerforum.com/forums/threads/full-throttle-runaway-vehicle.442563/) that a throttle control cable may have an issue or defect that is causing the throttle spring to not release, or the cable is hanging up. Please see included Explorer forum link above.

Jan 29, 2022

I BOUGHT A USED 2005 FORD RANGER XLT 4X4 IN JULY OF 2018 BEING A ONE OWNER VEHICLE AND LOW MILAGE AT THE TIME WHICH WAS ABOUT 65000 MILES I SAW IT ONLINE IN ONE OF THE LOCAL DEALERSHIPS IN TOWN. HE HAD A GREAT REPUTATION AND I WENT TO SEE HIM GOT A GREAT DEAL SO I BOUGHT IT.. THE TRUCK PASSED MA STATE INSPECTION WITH NO ISSUES. I KEPT GETTING NOTICES FROM FORD FOR AN AIR BAG RECALL SO I WENT TO A LOCAL FORD DEALER TO HAVE MY AIRBAGS REPLACED FOR RECALL AND WANTED THEM TO CHECK THE UNDERCARRIDE AS WELL AS I HAVE SEEN HORROR STORIES ONLINE AS HOW BAD THESE UNDERCARRIDGES WERE ON THE FORD RANGERS. THE LOCAL FORD DEALERSHIP DID A SAFETY INSPECTION AND FOUND THAT MY ENTIRE UNDERCARRIDGE HAS BEEN RUSTED OUT. THERE IS A MISSING CROSSMEMBER BAR WHICH I GUESS SUPPORTS THE VEHICLE THAT IS COMPLETELY GONE AND ALL HOIST POINTS ARE BAD VEHICLE IS COMPRIMISED DUE TO ALL THE RUST AND IS NOT SAFE FOR DRIVING. A CERTIFIED FORD DEALER GAVE ME THIS WRITTEN ESTIMATE AND I ASKED IF FORD WOULD HELP ME HERE ABOUT MAYBE RECALLING THE FRAMES AS I HAVE SEEN A LOT OF ONLINE STUFF THAT THESE FRAMES WERE AS BAD AS THE TOYOTA TUNDRAS AND TOYOTA AT LEAST RE-CALLED THE FRAMES CAN FORD DO THE SAME THEY SAID NO. I WOULD THINK A REPUTABLE FORD DEALER WHO GAVE ME THIS ESTIMATE WOULD AT LEAST TRY TO HELP ME BUT NO. I HAVE WRITTEN TO FORD BUT NO ANSWER AS OF YET. I AM FIGHTING NOW WITH THE LOCAL DEALERSHIP WHO SOLD ME THE VEHICLE IN THE FIRST PLACE AS IT SHOULD HAVE NEVER BEEN SOLD AND ALSO LOOKING INTO ANY RECOURSE I HAVE WITHIN MA LAW. THIS DOESNT SEEM RIGHT YOU HAVE AN ENTIRE UNDERCARRIDGE THAT HAS BEEN ROTTED OUT FOD KNOWS ABOUT THIS ISSUE AND WILL NOT DO ANYTHING ABOUT IT WHAT ARE THEY WAITING FOR SOMEONE TO GET SERIOUSLY HURT OR EVEN DIE IN AN ACCIDENT HERE. THES TRUCKS SHOULD BE RECALLED.

Nov 03, 2019

THIS 2005 TRUCK WAS KEPT IN A GARAGE FOR THE LAST 13 YEARS, ONLY HAS 50,000 MILES ON IT AND THE FRAME IS COMPLETELY ROTTED AND RUSTED. HAD THIS TRUCK INSPECTED THIS WEEK AND WAS TOLD IT NEEDS A NEW FRAME TO PASS INSPECTION. THE REST OF THE TRUCK IS IN PERFECT CONDITION. IT IS OUTRAGEOUS THAT THIS FRAME HAS ROTTED AWAY WHEN NOT EXPOSED TO THE ELEMENTS AND KEPT IN VERY GOOD CONDITION MY MECHANIC TOLD ME THAT THIS IS A COMMON PROBLEM WITH FORD RANGERS. SOMETHING SHOULD BE DONE BY FORD ABOUT THIS DEFECT LIKE TOYOTA DID... PLEASE LOOK INTO THIS. I AM VERY UPSET THAT I CAN NO LONGER DRIVE MY TRUCK. I LIVE ON SOCIAL SECURITY AND CAN NOT AFFORD A NEW VEHICLE. THANK YOU FOR YOUR TIME.

Dec 03, 2018

THE ENTIRE REAR OF MY TRUCK THE REAR BED LINER AND FRAME OF MY TRUCK IS ALL RUSTED OUT I WAS TOLD THAT THIS IS A KNOWN PROBLEM FOR THESE TRUCKS AND WOULD LIKE FORD TO RECALL THIS AS THIS IS DANGEROUS I LIVE MY TRUCK BUT DRIVING IT IS NOT SAFE

Aug 28, 2018

FRAME HAS EXTREME RUST DAMAGE. THERE ARE HOLES THROUGH THE FRAME. MY MECHANIC EXPRESSED A LOT OF CONCERN ABOUT THE CONDITION OF THE FRAME STEEL AND SAID I SHOULD GET RID OF THE TRUCK. I AM RETIRED AND USE THE TRUCK FOR MY PERSONAL TRANSPORTATION.

Feb 16, 2017

+ 5 more complaints for this component

FUEL/PROPULSION SYSTEM

9 complaints

I WOULD BE DRIVING AND ALL OF A SUDDEN THE WHOLE VEHICLE WOULD JUST SHUT DOWN. THIS HAPPENED 3 OR 4 TIMES JUST GOING AT 25 TO 35 MPH. AT FIRST, I THOUGHT IT WAS A CLOGGED FUEL LINE SINCE IT WOULD SOMEHOW RESET ITSELF AFTER HAVING IT TOWED TO MY MECHANIC SO I REPLACED THE FILTER EVEN THOUGH I COULD SEE NOTHING WRONG. WHEN IT HAPPENED AGAIN ON A BACKCOUNTRY ROAD THE MECHANIC SAID IT WAS PROBABLY THE FUEL PUMP SO I HAD THE WHOLE THING REPLACED. IT HAPPENED ONE MORE TIME AFTER THAT, I WAS PULLING ONTO A MAJOR HIGHWAY AND HAD JUST GOTTEN UP TO SPEED 55 MPH AND THERE WAS A TRACTOR-TRAILER BEHIND ME WHEN ALL OF A SUDDEN AGAIN EVERYTHING SHUT DOWN. LUCKILY I HAD ENOUGH MOMENT BUILT UP I WAS ABLE TO COAST TO THE SIDE OF THE ROAD BEFORE GETTING HIT BY THE TRACTOR-TRAILER. I FINALLY LOOKED ONLINE AND FOUND THAT SOMEONE HAD MENTIONED THE SAME PROBLEM IT MAY BE THE INERTIA SWITCH. I CALLED UP A LOCAL DEALERSHIP AND HAD ASKED THE PARTS PERSON IF THE HAD A REPLACEMENT AND IF HE HEARD ANY PROBLEMS ABOUT IT. I WAS TOLD IT WOULD HAVE TO BE ORDERED BECAUSE THEY WERE OUT OF THEM, THEY HAD SOLD A FEW IN THE PAST MONTHS. WHEN I EXPLAINED THE PROBLEM I WAS TOLD OH YES WE HAVE HEARD ABOUT THAT HAPPENING BUT THERE WAS NO RECALL. I EXPLAINED HOW IT COULD BE A SAFETY PROBLEM AND WAS TOLD THAT IT MUST NOT BE HAPPENING ENOUGH FOR IT TO BE A RECALL. I RECENTLY FOUND THIS SITE AND HAVE SEEN THAT I AM NOT THE ONLY ONE WHO HAD THIS HAPPEN SO AT LEAST I KNOW I WASN'T CRAZY. *TR

Apr 18, 2020

ENGINE STALLED OSTENSIBLY FOR LACK OF FUEL. FIRST ENGINE STALL EPISODE OCCURRED WHILE VEHICLE WAS TURNING LEFTWARD INTO DRIVEWAY AT ABOUT 2 MPH AND AT APPROX 5 DEGREE ANGLE OF INCLINATION. VEHICLE WAS TOWED FROM WHERE IT CAME TO REST TO REPAIR SHOP WHERE DIAGNOSIS WAS FUEL PUMP FAILURE RESULTING IN REPLACEMENT OF THE FUEL PUMP (FORD OEM PART.) VEHICLE PERFORMED RELIABLY THEREAFTER FOR A PERIOD OF APPROX 39 MONTHS WITHOUT STALLING. SECOND EPISODE OCCURRED AFTER VEHICLE SHUT OFF AND RESTING ON FLAT DRIVEWAY SURFACE OVERNIGHT. THE FOLLOWING MORNING ENGINE CRANKED BUT WOULD NOT FIRE OR START. AGAIN TOWED TO DIFFERENT REPAIR SHOP WHERE DIAGNOSIS WAS AGAIN FUEL PUMP FAILURE HOWEVER UPON ATTEMPT TO RESTART FOLLOWING PUMP REPLACEMENT, ENGINE WOULD NOT FIRE OR START. TROUBLESHOOTING REVEALED FUEL INERTIA SWITCH REQUIRED RESET AFTER WHICH ENGINE STARTED, SYSTEM TESTED OK AND VEHICLE PERFORMED SEEMINGLY PROPERLY FOR NEXT 10 DAYS. MOST RECENT (3RD) STALLING EPISODE OCCURRED AT TRAFFIC CONTROL LIGHT IN HEAVY TRAFFIC IMMEDIATELY UPON ACCELERATION FROM FULL STOP ON LEVEL SURFACE AND ATTEMPTING TO TRAVEL DIRECTLY FORWARD WITH NO TURN OF THE WHEEL. FOLLOWING REMOVAL FROM ROADWAY, ENGINE COULD NOT BE RESTARTED UNTIL AFTER FUEL INERTIA SWITCH WAS RESET. VEHICLE THEN RAN UNDER ITS OWN POWER ADDITIONAL 2 MILES TO HOME WHERE IT REMAINS PENDING FURTHER TROUBLESHOOTING AND REPAIR.

Feb 13, 2018

Injuries: 1

FORD RANGER 2005 4 CYLINDER FUEL CUTOFF SAFETY SWITCH CUTS OFF WITHOUT WARNING, FIRST TIME IN 2012 WHILE OUT OF STATE, TRAVELING ON THE INTERSTATE AT 70 MPH, TRIED TO PULL OVER, BUT NOT MUCH OF A ROAD SHOULDER. I HAD IT TOWED 11 MILES TO AN UNFAMILIAR GARAGE THAT, REPLACED THE SWITCH FOR $360. IN 2015 SWITCH FAILED, TOWED TO A LOCAL GARAGE AND REPAIRED. I BELIEVE THEY RESET THE SAFETY SWITCH AND CHARGED $70 DOLLARS. RESEARCHED THE PROBLEM AND DISCOVERED HUNDREDS OF COMPLAINTS, FOUND OUT THE SWITCH IS PROBABLY DEFECTIVE AND CAN BE RESET. I CANNOT START MY VEHICLE MORE THAN THREE TIMES WITHOUT RESETTING THE SWITCH. THE FORD DEALER WANTED TO REPLACE MY FUEL PUMP FOR $850. I DOUBT THAT IS THE PROPER FIX. THIS SITUATION IS EXTREMELY AGGRAVATING AND QUITE DANGEROUS. I DON'T KNOW WHY FORD IS TURNING AWAY FROM THIS PROBLEM OTHER THAN THE NUMBER OF OWNERS THAT HAVE THIS PROBLEM. SOMEONE IS GOING TO GET HURT. I LOVE MY TRUCK, I HATE THE INCONVENIENCE. THERE ARE OTHER MODELS EXPERIENCING THIS SAME PROBLEM. THE CUTOFF CAN OCCUR AT ANY TIME, WHILE IN MOTION OR STANDING STILL.

Sep 24, 2017

THE GAS ACCIDENT CUT OFF SWITCH CUT OUT RANDOMLY DURING DRIVING ON A SMOOTH FLAT ROAD AT HIGHWAY SPEED AS WELL AS AROUND TOWN AT SLOWER SPEED. A LESS EXPERIENCED DRIVER COULD HAVE HAD A DEADLY. ACCIDENT. I RESET IT SEVERAL TIMES AND HAD TO REPLACE IT. FORD SHOULD HAVE HAD A RE-CALL ON THIS VERY DANGEROUS PROBLEM. I HAVE THE OLD SWITCH IF IT IS NEEDED.

Aug 10, 2016

LEAKING GAS FROM FUEL PUMP FUEL PUMP HAS BIG CRACK IN PLASTIC WHERE FUEL LINE COMES OUT

Jun 22, 2015

+ 4 more complaints for this component

SUSPENSION,STRUCTURE

8 complaints

THE LEAF SPRING BUSHINGS PUSHED THREW THE ROTTED FRAME AND POKED HOLES IN THE BED OF THE TRUCK .THE SPARE TIRE WAS HANGING ON THE GROUND WHEN I GOT HOME ONE DAY. NOW MY INSPECTION STATION WONT PUT A INSPECTION STICKER ON IT BECAUSE THEY SAY ITS TO DANGEROUS.TOYOTA HAD THIS PROBLEM AND ETHER REPAIRED THE VEHICLE OR REPLACED IT. *TR

May 15, 2020

THE PASSENGER SIDE REAR SHACKLE RUSTED COMPLETELY OFF AND THE LEAF SPRING ALMOST WENT THROUGH THE BED OF THE TRUCK. THE TRUCK WAS NOT DRIVABLE UNTIL THE PASSENGER SIDE REAR SHACKLE WAS REPLACED. THIS WAS DISCOVERED AFTER DRIVING OVER A BUMP IN THE ROAD, HEARING A LOUD BANG AND EXPERIENCING A JOLT. ONCE PARKED THE TRUCK WAS COMPLETELY LOOKED OVER, WHICH LEAD TO MORE DISCOVERIES. A GIANT RUST HOLE HAS FORMED IN THE FRAME BEHIND THE SHACKLE ON THE DRIVER'S SIDE REAR AREA OF THE TRUCK. THIS TRUCK HAS BEEN WELL MAINTAINED THROUGHOUT THE YEARS AND WAS PROFESSIONALLY UNDER COATED A COUPLE YEARS AGO WITH NO HOLES IN THE FRAME OR VISIBLE RUST AT THAT TIME. THE FRAME HAS DETERIORATED RAPIDLY. LUCKILY I DID NOT TRY TO TOW ANYTHING WITH THIS TRUCK BECAUSE THE REAR PART OF THE FRAME LIKELY WOULD HAVE BEEN RIPPED OFF, LOSING WHAT WAS BEING TOWED AND POTENTIALLY CAUSING AN ACCIDENT. THERE IS ALSO A LARGE HOLE FORMING IN THE BED OF THE TRUCK.

Apr 21, 2019

FRAME ROTTED AWAY IN THE BACK SIDE, REAR LEAF SPRINGS FELL OFF, SPARE TIRE READY TO FALL OFF.

Aug 01, 2018

VEHICLE HAS 37850 MILES LOOKS LIKE NEW AND THE FRAME HAS ROTTED AWAY SPRING HANGERS AND THE COMPLETE FRAME ITSELF YOU CAN PUT YOUR FINGERS THROUGH IT AND GAS TANK STRAPS ALSO GONE

Jul 17, 2017

TL* THE CONTACT OWNS A 2005 FORD RANGER. THE CONTACT STATED THAT THE REAR AND SPARE TIRE FRAME ROTTED. THE FAILURE CAUSED THE SPARE TIRE TO DROP. THE VEHILCE WAS TAKEN TO AN INDEPENDEDNT MECHANIC WHERE THE TECHNICIAN DIAGNOSED THAT THE FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 59,000. UPDATED 6/8/15*CN

Mar 11, 2015

+ 3 more complaints for this component

ELECTRICAL SYSTEM

6 complaints

TL* THE CONTACT OWNS A 2005 FORD RANGER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 60 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE ABLE TO BE RESTARTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 127,000.

Jul 18, 2016

TL* THE CONTACT OWNS A 2005 FORD RANGER. THE CONTACT STATED THAT THE INERTIA SWITCH MALFUNCTIONED, CAUSING THE VEHICLE TO STALL WHILE THE CONTACT ATTEMPTED TO PARK. THE VEHICLE WOULD ALSO SPORADICALLY FAIL TO START. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC, WHO ADVISED THE CONTACT THAT THE INERTIA SWITCH NEEDED TO BE REPLACED. THE CONTACT DID NOT HAVE THE SWITCH REPLACED. THE FAILURE MILEAGE WAS 52,000.

Apr 22, 2013

ENGINE DIED WHEN SLOWING FOR A TURNING VECHICLE AN BUSY CITY STREET. ENGINE WOULD NOT START AND WAS UNABLE TO MOVE VECHICLE OUT OF TRAFFIC LANE UNTIL TOW TRUCK ARRIVED. REPAIR FACILITY ENGINE ANALYSIS IDENTIFIED THE FUEL PUMP INERTIA SHUTOFF SWITCH WHICH AS THE FAULT. IT WOULD NOT RESET AND WAS REPLACED.

Aug 15, 2011

FUEL SHUT OFF SWITCH - THE WIRE HARNESS CONNECTING TO THE FUEL SHUT OFF SWITCH ARE MELTED. FORD REPLACED ONE OF THESE SWITCHES DURING MY WARRANTY PERIOD AND SINCE THEN I HAVE REPLACED THIS SWITCH TWICE. I NOW NOTICE THAT THE HARNESS CONNECTED TO THIS SWITCH HAS WIRES THAT ARE MELTED. THIS SWITCH HAS ACTIVATED NUMEROUS TIMES WHILE I HAVE BEEN DRIVING AND WHEN THIS HAPPENS THE VEHICLE FUEL IS INTERRUPTED AND VEHICLE STALLS. I HAVE HAD THIS HAPPEN ON INTERSTATE 4 AND ON VARIOUS OTHER ROADS. I FIND IT HARD TO BELIEVE THAT MY VEHICLE IS THE ONLY ONE THIS HAPPENS TO. I RECENTLY PICKED UP A NEW SWITCH WHICH HAS BEEN REVAMPED WITH AN ADDITIONAL WIRING HARNESS AND A NEW CONNECTION BRACKET. THE PROBLEM IS THAT THE OLD HARNESS THAT THIS WILL BE ATTACHED TO HAS BARE WIRES EXPOSED WITH NO INSULATION COVERING THEM. I AM CONCERNED THAT THIS CONSTITUTES A FIRE HAZARD. I HAVE SPOKEN TO THE FORD SERVICE DEPARTMENT IN LAKELAND, FL. BUT HAVE HAD NO REASONABLE EXPLANATION ON THIS PROBLEM. *LN

Jan 16, 2011

2005 FORD RANGER EDGE. ENGINE STALLING DUE TO FAULTY FUEL CUTOFF SWITCH WHICH GOT HOT ENOUGH TO MELT THE PLASTIC SWITCH ITSELF. TRUCK STALLED 20-30 TIMES TOTAL WITH HALF OF THOSE TIMES AT FREEWAY SPEEDS. *TR

Nov 09, 2010

+ 1 more complaint for this component

TIRES

6 complaints

TL* THE CONTACT OWNS A 2005 FORD RANGER. WHILE DRIVING AT AN UNKNOWN SPEED, THE LOW TIRE PRESSURE MONITORING SYSTEM WARNING LIGHT ILLUMINATED. THE CONTACT DISCOVERED THAT ALL FOUR TIRES WERE LOSING AIR. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN ADDED AIR TO THE TIRES. THE FAILURE RECURRED MULTIPLE TIMES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 29,500. THE VIN WAS UNAVAILABLE.

Jan 26, 2016

TL* THE CONTACT OWNS A 2005 FORD RANGER EQUIPPED WITH HANKOOK RADIAL H714 TIRES, TIRE SIZE 225/70/15. THE DOT NUMBER WAS 1GUUAPH. WHILE DRIVING APPROXIMATELY 65 MPH, THERE WAS A LOUD NOISE OUTSIDE OF THE VEHICLE. THE CONTACT MANEUVERED TO THE SIDE OF THE ROAD AND NOTICED THE FRONT PASSENGER SIDE TIRE EXPLODED. THE TIRE WAS REPLACED WITH A SPARE TIRE. THE MANUFACTURER WAS MADE AWARE OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 82,000.

Jun 16, 2011

CONTINENTAL TIRES.....I OWN 2 VEHICLES THAT HAVE COME EQUIPPED WITH CONTINENTAL TIRES AND FOUND THAT OVER TIME BOTH SETS OF TIRES HAVE WORN OUT DUE TOO POOR QUALITY OF THE TIRE. I HAVE GONE ON LINE AND LOOKED UP ON THE WEB SITE UNDER CONTINENTAL TIRE AND CLICKED ON COMPLAINTS ABOUT THESE TIRES AND IT IS ALARMING HOW MANY PEOPLE ARE FINDING THAT THE TIRES FROM CONTINENTAL ARE POORLY MADE AND THE QUALITY OF THESE TIRES IS PUTTING PEOPLE IN HARMS WAY , DUE TO BLOWOUTS , TREAD SEPARATION, PREMATURE WARE . I LIVE IN TUCSON AZ AND JUST ABOUT EVERY TIRE DEALER WITHIN 20 MILES OF ME WONT EVEN RECOMMEND A TIRE BUILT BY CONTINENTAL. REPLACING THESE TIRES WITH SOMETHING DIFFERENT IS THE ONLY OPTION TO BE SURE YOU DON'T HAVE HAPPEN TO YOU ,WHAT MOST PEOPLE HAVE HAD HAPPEN TO THEM , AFTER YOU READ THE COMPLAINTS POSTED ON THE WEB SITE OF CONTINENTAL TIRE, I FIND IT NECESSARY TO FILE A COMPLAINT ABOUT THESE TIRES AND THE COMPANY. I FEEL THAT SOMEONE NEEDS TO READ THE COMPLAINTS ON THE WEB SITE, AND TAKE A LOOK TO SEE IF THERE IS SOMETHING THAT CAN BE DONE , TO GET ANSWERS AS TO WHY CONTINENTAL FEELS THAT THERE'S NO PROBLEM WITH THERE TIRES. ON MY 2005 FORD RANGER THE TIRES HAD 30,000 MILES ON THEM AND IN THE OWNERS MANUAL , THE TIRES HAD A 6 YEAR PRO-RATED WARRANTY ON THEM. THE TIRE DEALER HERE IN TUCSON WAS TOLD BY CONTINENTAL THAT THEY DIDN'T COVER THE TIRE FROM NORMAL WEAR. THE DEALER EXPLAINED TO CONTINENTAL THAT THE TIRES IN QUESTION WERE PRE-MATURELY WEARING OUT ON THE INSIDE EDGES AND THE MIDDLE OF THE FACE OF THE TIRE. CONTINENTAL MORE LESS SAID TOO BAD AND WOULDN'T DO ANY THING ABOUT IT. THIS HAPPENED ON MY WIFE'S FORD ESCAPE ALSO, AND WE HAD REPLACED HER ORIGINAL TIRES THAT CAME ON HER CAR , WITH THE SAME CONTINENTAL BRAND, AND THEY ONLY LASTED 23,000 MILES . THESE TIRES WERE RATED FOR 50,000. I NOT SURE WHAT CAN BE DONE ABOUT THIS, BUT I FEEL PEOPLE NEED TO LET SOME CONSUMER COMPLAINT GROUPS KNOW THERE IS A PROBLEM THAT EXISTS HERE. *TR

Jan 12, 2010

VALVE STEM FAILURE, 2005 FORD RANGER. I'VE BEEN DRIVING FOR 30 YEARS, AND NEVER HAD A VALVE STEM JUST CRACK WHILE DRIVING CAUSING A LOSS OF PRESSURE. THERE IS A RECALL OF SOME KIND ON 06 FORD PRODUCTS, I JUST WANTED YOU TO KNOW THAT IT COULD BE BIGGER THAT WHAT WAS THOUGHT. *TR

Dec 04, 2008

2005 FORD RANGER. WHILE DRIVING 65 MPH ON THE OHIO TURNPIKE SWITCHING TO THE FAR RIGHT LANE, THE BACK RIGHT TIRE BLEW OUT AND THE TRUCK SWERVED AND THE UHAUL TRAILER FLIPPED SEVERAL TIMES. *MC (OHIO TRAFFIC CRASH REPORT)*JB

May 22, 2007

+ 1 more complaint for this component

SUSPENSION

5 complaints

THE LEAF SPRING SHACKLES ROTTED THREW THE FRAME AND THE SPARE TIRE HOLDER DROPPED THE SPARE TIRE WHILE DRIVING THIS IS DANGEROUS

Oct 22, 2019

TL* THE CONTACT OWNS A 2005 FORD RANGER. WHILE DRIVING APPROXIMATELY 35 MPH, AN ABNORMAL NOISE WAS COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT BOTH LEAF SPRING SHACKLES WERE ROTTING THROUGH THE FRAME AND NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 59,000.

Aug 01, 2019

I AM CURIOUS WHY THERE HAS BEEN NO RECALL ON THE FORD RANGER FRONT WHEEL BEARING ISSUE WITH THE HUNDREDS OF COMPLAINTS OUT THERE. WE THE CONSUMER DRIVING ON THE ROADS NEED TO BE PROTECTED BETTER. *TR

Jul 09, 2011

DEAR SIRS; I AM A NIGHT SHIFT AUTOWORKER AT FORD RANGER PLANT IN ST PAUL. MY JOB IS TO BUILD AND MOUNT A SWAYBAR ON THE REAR AXLE. FOR OVER A YEAR I HAVE EXPRESSED MY CONCERNS TO MANAGEMENT ABOUT THE PROPER ANGLE TO MOUNT THE SWAYBAR BRACKETS. I FEEL LIKE I HAVE BEEN STONEWALLED, TOLD THINGS LIKE "IT DOESEN'T MATTER". IT DOES MATTER TO OUR CUSTOMERS. THEY WANT THAT SWAYBAR TO BE PERFECT. IT MIGHT MAKE ALL THE DIFFERENCE IF THERE HAS TO BE A HARD SWERVE TO AVOID A DEER OR CHILD IN THE ROAD. THERE NEEDS TO BE SOME NUMERICAL POINT OF REFERENCE ON RECORD IN THE MANUFACTURING PROCESS GUIDELINES. THE OPERATOR EITHER NEEDS A TONGUE AND GROOVE SYSTEM ON THE AXLE AND SWAYBAR BRACKET AND/OR SOME TYPE OF FIXTURE THAT WOULD ACT AS A GUIDE TO INSURE THE CORRECT ANGLE IS ACHIEVED FOR EVERY BUILD PROCESS. THERE ALSO NEEDS TO BE AN INSTRUMENT THAT CAPABLE OF CHECKING EACH ONE FOR CORRECT ANGLE. *NM

Mar 15, 2006

DT: CONTACT STATED THERE IS VIBRATION IN THE REAR END OF VEHICLE WHILE GOING APPROXIMATELY 50 MPH. THE SERVICE DEALER CAN'T FIND THE PROBLEM. THEY DID REPLACE THE TIRES ON THE VEHICLE, BUT THIS DID NOT RESOLVE THE PROBLEM.*AK

May 26, 2005

ENGINE

5 complaints

COUPLE DAYS AFTER BUYING VEHICLE TRUCK BROKE DOWN DEALER REFUSED TO TAKE RESPONSIBILITY ALSO THE BIGGEST COMPLAINT IS DEALER REFUSES TO GIVE US LICENSE PLATES WE PURCHESD THE VEHICLE NOVEMBER 12, 2015 AND DEALER IS HOLDING PLATES HOSTAGE WE DO NOT OWE HIM ANY MONEY

Jan 07, 2016

ENGINE MISFIRES AT IDLE CEL FLASHING NEEDS HEADS. *TR

Jan 11, 2015

ENGINE BEGINS TO RUN VERY ROUGH. TOOK TO MECHANIC AND WAS TOLD MY 3.0 V6 IS SUFFERING FROM WELL KNOW (2004 - 2006) CYLINDER HEAD FAILURE - VALVE RECESSION. NEW HEADS ARE NEEDED TO FIX THE PROBLEM. COST OF REPAIR IS APPROX, $2800. HEAD / VALVE FAILURE / POOR DESIGN OF HEAD IS APPARENTLY WELL KNOWN BY FORD. FUEL LEAKAGE INTO THE FAILED CYLINDER OR CYLINDERS COULD BE A FIRE HAZARD IF NOT REPAIRED AND DRIVEN CONTINUOUSLY. *TR

Mar 05, 2014

LOUD SQUEAL FOR SEVERAL DAYS THOUGHT IT WAS TENSION PULLEY. THAT WAS REPLACED WITH NO CHANGE. A FEW DAYS LATER GOING DOWN THE ROAD. A VERY LOUD SQUEAL FROM THE ENGINE AREA AND SMELL OF BURNING RUBBER. LATER WAS DETERMINED THE VIBRATION DAMPENER HAD COME APART. THE RUBBER HAD COME PART ALLOWING THE GROOVE SECTION THE BELT RIDES ON TO SLIP TOWARD THE BACK UP AGAINST THE FRONT COVER. IN LOOKING ONLINE FOR INFORMATION IT WAS DISCOVERED THIS IS A COMMON PROBLEM WITH EXPLORER AND RANGERS WITH THE 4.0 ENGINE. A LOT OCCUR WITH LOW MILES ON THE VEHICLE AND SOME RESULT IT MAJOR REPAIRS AS THE PULLEY FLIES OFF TAKING OUT THE RADIATOR. I WAS ABLE TO REPLACE MINE BECAUSE I AM A MECHANIC AND HAVE THE TOOLS TO DO THE JOB. SO MY REPAIR BILL WAS NOT AS MUCH AS OTHERS HAD STATED. *TR

Dec 17, 2013

WHILE DRIVING DOWN THE HIGHWAY, THE HARMONIC BALANCER FAILED. THE PULLEY SEPARATED FROM THE REST OF THE BALANCER AND SLID BACK TO DESTROY THE CRANKSHAFT POSITION SENSOR. ONCE THE SENSOR FAILED, THE ENGINE STALLED. I WAS ABLE TO PULL OVER TO THE SIDE OF THE HIGHWAY, BUT THIS SUDDEN FAILURE IS DANGEROUS AND IF I WAS NOT ABLE TO GET TO THE SIDE OF THE HIGHWAY COULD CAUSE AN ACCIDENT. AFTER A LITTLE RESEARCH ON THE INTERNET THERE ARE SEVERAL OCCURRENCES OF THE SAME ISSUES ON THE FORD 4.0 ENGINE ON RANGER / EXPLORER. LOOKING AT THE NHTSA COMPLAINTS SITES THERE ARE ALSO SEVERAL OCCURRENCES OF THE SAME ISSUE (MORE THEN 1 YEAR, MORE THEN 1 MODEL): ODI ID NUMBER : 10356858, ODI ID NUMBER : 10356913. ODI ID NUMBER : 10450902, ODI ID NUMBER : 10383429, ODI ID NUMBER : 10243439, ODI ID NUMBER : 10168915, ODI ID NUMBER : 10351279, ODI ID NUMBER : 10390200, ODI ID NUMBER : 10302026, ODI ID NUMBER : 10279040. THERE MAY BE MORE, BUT I WAS TIRED OF LOOKING. *TR

Jun 06, 2012

FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM

5 complaints

DRIVING ON I75 WHEN ENGINE STOPPED. I LOST ALL POWER. WAS ABLE TO COAST OFF THE ROAD AND ONTO THE SHOULDER. AFTER FIVE MINUTES, TRUCK STARTED AND DROVE HOME WITHOUT ANY FURTHER PROBLEM. CONTINUED TO HAVE SAME PROBLEM, DIDN'T MATTER WHAT SPEED I WAS DRIVING OR IF I WAS STOPPED AT A LIGHT, AND IT WOULD STOP REPEATEDLY IN ONE WEEK OR GO FOR MONTHS WITHOUT A PROBLEM. TRUCK WOULD STOP AND WOULD EVENTUALLY RESTART WITHIN A COUPLE MINUTES OR UP TO 30 MINUTES AFTER IT HAD STOPPED. I REPEATEDLY HAD TO COAST OR PUSH THIS TRUCK FROM THE ROADWAY WITHOUT ANY POWER STEERING. IN EARLY 2011, THE TRUCK STOPPED THREE TIMES IN ONE DAY. THE THIRD TIME, IT STOPPED IN FRONT OF FRIENDLY FORD, MONROE, MI. THEY KEPT IT FOR TWO WEEKS BUT IT ONLY STOPPED RUNNING FOR THEM ONE TIME AND IT REPAIRED ITSELF BEFORE THEY COULD FIND THE PROBLEM. IN MAY OF 2012, IT BEGAN STOPPING MULTIPLE TIMES IN ONE DAY. IT STOPPED AND WOULD NOT RESTART AND I HAD IT TOWED TO CREST FORD IN FLAT ROCK, MI. THEY DISCOVERED THE FUEL SHUTOFF INERTIA SWITCH HAD FAILED AND REPLACED IT AND THE PIG TAIL WIRING HARNESS. IT APPARENTLY HAD OVERHEATED FOR SOME TIME AND HAD MELTED THE WIRING HARNESS INTO THE SWITCH. I PAID $367.94 FOR THESE REPAIRS. AT THIS TIME THE TRUCK ONLY HAD 28,370 MILES ON IT. THE TRUCK WAS USED VERY LITTLE AND WAS ALWAYS KEPT INSIDE MY GARAGE. THE DEALER TOLD ME TO CONTACT FORD FOR POSSIBLE REIMBURSEMENT. FORD TOLD ME THEY DID NOT HAVE A RECALL FOR THIS PROBLEM AT THIS TIME BUT TO KEEP MY RECEIPT IN CASE OF A FUTURE RECALL. I FEEL THIS IS A SAFETY PROBLEM. THIS SWITCH IS DESIGNED TO SHUT OFF THE FUEL PUMP DURING A CRASH SO AS NOT TO FEED A FIRE. I GOOGLED FOR "FORD RANGER DEFECTIVE INERTIA SWITCH," AND FOUND THOUSANDS OF SIMILAR COMPLAINTS WHERE THEIR RANGER WOULD SUDDENLY STOP AND EVENTUALLY WOULD REQUIRE THE INERTIA SWITCH TO BE REPLACED AND IN SOME INSTANCES, IT WAS REPLACED AS MANY AS THREE TIMES DURING OWNERSHIP. *JB UPDATED 07/19/12

Jun 26, 2012

DRIVING ON FREEWAY APPROXIMATELY 30 TO 40 MINUTES AT 55-70 MPH AND ENGINE SHUTS DOWN WITH NO WARNING. PULL OVER WAIT A FEW MINUTES AND ENGINE STARTS. DRIVE ANOTHER 30-40 MINUTES AND ENGINE SHUTS DOWN. PULL OVER WAIT A FEW MINUTES ENGINE STARTS. *TR

Aug 14, 2011

DRIVING ON FREEWAY APPROXIMATELY 30 TO 40 MINUTES AT 55-70MPH AND ENGINE SHUTS DOWN WITH NO WARNING. PULL OVER WAIT A FEW MINUTES AND ENGINE STARTS. DRIVE ANOTHER 30 TO 40 MINUTES AND ENGINE SHUTS DOWN. PULL OVER WAIT A FEW MINUTES - ENGINE STARTS. WENT TO PUT GAS IN TRUCK AND ENGINE WOULD NOT START. RESET FUEL INERTIA/SHUT DOWN SWITCH AND TRUCK STARTED. *TR

Aug 14, 2011

MY 19 YEAR OLD SON OWNS A 2005 FORD RANGER WE PURCHASED THROUGH A DEALER LAST YEAR. FOR THE LAST MONTH OR SO HE HAD TO RESET THE FUEL PUMP INERTIA SWITCH TO GET THE VEHICLE STARTED AGAIN. THIS IS VERY DANGEROUS SINCE ONE TIME HE WAS ON THE EXPRESSWAY GOING 65 AND THE TRUCK TURNED OFF ON HIM. IT'S HAPPENED TO HIM ABOUT 5 TIMES AND NOW HE IS AFRAID TO DRIVE IT. DON'T KNOW IF THE INERTIA SWITCH IS BAD OR IF SOMETHING ELSE IS CAUSING THIS. I HATE TO TAKE IT TO THE DEALER SINCE THEY TEND TO THROW PARTS AT IT AND NOT FIX THE PROBLEM. I THINK THIS IS SO DANGEROUS IT SHOULD BE RECALLED BY THE FORD DEALER. *TR

Jun 22, 2010

DRIVING EAST ON I-10 NEAR ONTARIO, CAL AT 70 MPH 5/22/2010 9PM, TRUCK DIED THE INERTIA FUEL SWITCH WAS OPEN . HAD TO DRIVE WITH SON HOLDING DOWN ON THE BUTTON TO KEEP TRUCK RUNNING TO GET OFF FREEWAY AT 4TH ST. INERTIA SWITCH IS DEAD USED A PAPER CLIP ON WIRES TO DRIVE HOME. ALSO THE WIRE CONNECTOR TO THE INERTIA WAS MELTING SOME. FIRST TIME THIS HAPPEN IS IN OCT 14 2005 AND 4 OR 5 TIMES SENSE. *TR

May 24, 2010

ENGINE AND ENGINE COOLING

5 complaints

2005 FORD RANGER EDGE. CONSUMER STATES PROBLEM WITH HARMONIC BALANCER IN ENGINE. *TGW

Mar 01, 2012

I WAS COMING DOWN OFF 57 IN RUSH TRAFFIC WHEN THE CAR DIED UNEXPECTEDLY. COMPLETELY SHUT OFF, NO WARNING, AND WOULD NOT START AGAIN. SEVERAL TRIES, MORE GAS, MORE SHUT OFFS,SCREAMING HORNS AND I GOT IT TO THE GAS STATION OFF THE HIGHWAY. IT WENT TO GARAGE. ITS EXHAUST VALVE, WIRES AND PLUGS WERE CHANGED. DIED ON DRIVE OFF THE GARAGE. WENT IN, HAD MORE REPAIRS. DIED IN PARKING LOT. HAD COMPUTER DIAGNOSTICS. 172 AND 174 WERE DIAGNOSED-FAILURE OF COMPUTER IN EXHAUST SYSTEM AND MASS AIR VALVE CONTROL. BASICALLY, THE EXHAUST SYSTEM FAILED AND SHUT OFF THE ENGINE. ONE OF THE HEADS IS ALSO SUSPICIOUS.EXHAUST LEAKS ARE BAD FOR THE ENGINE. ALL THIS, OVER $1,000 REPAIRS, ON TOP OF TRANSMISSION LEAK, TWO SETS OF BRAKE PADS AND TWO SETS OF TIRES, IN A TRUCK BETWEEN 39,000 - THAT IS WHEN IT STARTED- AND 50,000 MILES. IN CASE YOU DON'T KNOW THIS, RIGHT AFTER THE FACTORY WARRANTY EXPIRED, THE TRUCK FELL APART. I FOUND OUT THAT ONE PERSON DIED OF SUCH FAILURE IN WASHINGTON STATE AND 2 WERE INJURED IN OREGON. ALL IN RANGER TRUCK. TRUCK IS WELL SERVICED, TIRES ARE NOT WORN AT ALL, HAVE LESS THAN 12,000 AND IT IS A KILLER TRUCK. FORD IS NOT RESPONSIVE TO THE FACT THAT THEIR TRUCK IS A LEMON. THEIR SERVICE CENTER: I BROUGHT IT TO YORBA LINDA FORD DEALER AT 39,000 BECAUSE THE IDLE WAS ROUGH, WAS TOLD IT WAS IN MY HEAD AND 12,000 LATER THE IDLE IS STILL DYING, KILLING THE ENGINE. *TR

Jan 16, 2012

2005 FORD RANGER WITH A 2.3 L ENGINE. CHANGED OIL AT 33K AND RETRIEVED A VALVE KEEPER. SUBSEQUENT REMOVAL OF OVERHEAD CAMS AND TIMING CHAIN ASSEMBLY (5.8 HOURS OF LABOR) AND 500+ DOLLARS OUT OF MY POCKET REVEALED NO VALVE KEEPERS WERE MISSING. THE DEALERSHIP GAVE ME A 1-800 NUMBER TO ASK QUESTIONS. *TR

Feb 13, 2011

TL* THE CONTACT OWNS A 2005 FORD RANGER. THE VEHICLE WAS TAKEN TO THE DEALER FOR A ROUTINE OIL CHANGE. THE MECHANIC INFORMED THE CONTACT THAT WHILE ATTEMPTING TO PERFORM THE OIL CHANGE, THE ENGINE BLEW. THE MECHANIC STATED THAT THE CAM-SHAFT PULLEY SEPARATED AND CAUSE THE TIMING TO JUMP AND LOCK THE ENGINE. THE FAILURE WAS SO SEVERE THAT THE ENGINE WAS UNABLE TO BE REBUILT. THE DEALER ADVISED THE CONTACT THAT THEY WERE NOT LIABLE FOR THE FAILURE. THE MANUFACTURER WOULD NOT PROVIDE ANY ASSISTANCE AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 112,000. UPDATED 9/13/10 *CN UPDATED 09/15/10

Jun 14, 2010

TL*THE CONTACT OWNS A 2005 FORD RANGER. HE STATED WHILE DRIVING AT 50 MPH HE NOTICED THAT HIS CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN A DEALER AND INSPECTED WHERE IT WAS DETERMINED THAT NUMBER FOUR CYLINDER WAS FAILING AND IN ORDER TO MAKE THE REPAIR THE VEHICLE WOULD NEED TO HAVE THE VALVE SEATS REPLACED. THE CONTACT WAS IN THE PROCESS OF CONTACTING THE MANUFACTURER. HE FEELS THAT THERE SHOULD BE A RECALL ON THE ALUMINUM HEAD VALVE SEATS BECAUSE THEY LOSE COMPRESSION WITH THE METAL THAT THE MANUFACTURER IS USING FOR THE ALUMINUM HEAD VALVE SEATS. THE FAILURE MILEAGE WAS 84,000 AND THE CURRENT MILEAGE IS 87,000. BL UPDATED 10/5/09 *CN UPDATED 10/07/09

Aug 26, 2009

POWER TRAIN

4 complaints

TL* THE CONTACT OWNS A 2005 FORD RANGER. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED ON AN INCLINE, THE GEAR SHIFTER SHIFTED OUT OF THE PARK POSITION INDEPENDENTLY AND THE VEHICLE ROLLED DOWNHILL AND ENDED UP IN A DITCH. THE CONTACT STATED THAT THE FAILURE RECURRED SEVERAL TIMES. BOTH THE DEALER AND THE MANUFACTURER WERE MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 116,732. *BF*JB

May 04, 2020

I HAVE LEARNED THE HARD WAY THAT THE SHIFTER ON THE 2005 FORD RANGER EXTENDED CAB WILL JUMP OUT OF PARK TO REVERSE. THIS HAPPEN TO ME (JUST RECENTLY) AND CAUSED ME TO TEAR UP MY DOOR AND FENDER ON THE VEHICLE (WHICH WILL BE COSTLY)...

May 04, 2020

Crash: 1

WHILE DRIVING AT APPROXIMATELY 35 MPH, WITH APPROXIMATELY 600 POUNDS OF WEIGHT IN THE BACK OR BED, ON A ROAD THAT REALLY WASN'T REAL SLICK SO I DIDN'T HAVE IT IN 4WD, AND SUDDENLY THE PICKUP VEERED TO THE LEFT AND HIT A CONCRETE JERSEY BARRIER. IT BOUNCED OFF AND WENT TOWARD THE RIGHT AND HIT A GUARD RAIL AND THEN ROLLED OVER ON TO ITS TOP. THE SHERIFF DEPUTY NOTICED THAT THE LEFT REAR WHEEL WAS MISSING AND THOUGHT IT WAS STRANGE THAT THE AXLE BROKE AT THAT LOW SPEED AND SITUATION. UPON INSPECTION OF THE BROKEN SURFACE ON THE PICKUP, HE NOTICED WHAT LOOKED LIKE RUST AS IF THE AXLE HAD CRACKED SOMETIME EARLIER AND FINALLY BROKE OFF. I LOOKED AT THE BROKEN SURFACES AND COULD SEE WHAT LOOKED LIKE POSSIBLE RUST AND SOMETHING WHITE. THE PICKUP NEVER HAS HANDLED SO STRANGELY SO I THOUGHT I WOULD TRY SEARCHING THE INTERNET FOR A SIMILAR OCCURRENCE. IT DIDN'T TAKE TOO LONG USING GOOGLE TO FIND ANOTHER INSTANCE WHERE A PERSON HAD REPORTED THE AXLE ON THE SAME SIDE ON, I BELIEVE, A 2004 RANGER HAD BROKEN AND THE PICKUP ROLLED. I TOOK SOME PICTURES OF THE BROKEN AXLE SURFACES, BUT IT IS NOT POSSIBLE TO ATTACH THEM TO THIS FORM. *TR

Jan 26, 2012

Crash: 1

Injuries: 1

2005 FORD RANGER - LEAKING TRANSMISSION FLUID FROM LINES RUBBING ON THE TRUCK FRAME. START AFTER 45K SERVICE AT DEALER. REPLACE FRONT BRAKE PADS WITH MACHINING LIGHT DUTY($468.43). NOT UNDER 10 YEAR WAR. PARTS AND LABOR $350.00. FOR TRANSMISSION LINES REPLACEMENT OCT. 29, 2008 FORD TOWN ALBANY SHOP. *TR

Oct 29, 2008

SUSPENSION,UNKNOWN OR OTHER

4 complaints

THE REPAIR SHOP INFORMED ME MY LEAF SPRING SHACKLES COULD NOT BE REPAIRED DUE TO SEVERE ROT OF THE FRAME IN THE REAR.TRUCK ONLY HAS 59000 MILES ON IT AND WAS WELL TAKEN CARE OF.THE REST OF THE TRUCK IS IN VERY GOOD SHAPE. THIS SHOULD NOT HAPPEN IS THERE A RECALL I DONT NO ABOUT? THANKYOU

Jun 01, 2019

SEVERELY RUSTED FRAME. WHILE THE SPARE TIRE HAS NOT FELL OFF YET, I HAD THE TRUCK UP ON A RACK AT PATRICK AIRFORCE BASE TO CHANGE THE OIL. I'VE KNOWN FOR A WHILE THAT THE FRAME IS BAD. THE TRUCK ONLY HAS 81,000 MILES ON IT, BUT LOOKING AT THE FRAME, IT WON'T LAST MUCH LONGER.

Apr 12, 2019

BOUGHT THIS TRUCK NEW AND AFTER ITS FIRST WINTER, WAS ALREADY SHOWING SEVERE RUSTING ON THE FRAME, NOW 11 YEARS LATER THE REAR FRAME IS RUSTED SO SEVERELY THAT THE REAR SPRING SHACKLES MOUNTING BRACKETS HAVE COMPLETELY FAILED AND THE METAL ON THE REAR FRAME RAILS IS SEVERELY RUSTED AND PERFORATED WHERE THE SPRING SHACKLE BRACKETS ATTACH TO THE FRAME, ALSO THE SPARE TIRE HOIST ASSEMBLY THAT HOLDS THE SPARE UNDER THE TRUCK , HAS ALSO FAILED AND IS DANGEROUS, CAN NO LONGER USE IT AS SPARE TIRE IS A SEVERE SAFETY HAZARD OF FALLING OFF THE TRUCK THAT COULD SEVERELY INJURE OR KILL ANOTHER MOTORIST SHOULD IT FALL OFF THE TRUCK AND STRIKE ANOTHER VEHICLE OR FLY THROUGH SOMEONES WINDSHIELD. NHTSA SHOULD REQUIRE THAT FORD RECALL THESE TRUCKS, AND BE REQUIRED TO REPLACE THE FRAMES, SIMILAR TO THE TOYOTA TUNDRA RECALL SEVERAL YEARS AGO FOR RUST PROBLEMS ON THEIR FRAMES, A TRUCK FRAME SHOULD NOT RUST AWAY ON A 2005 RANGER THAT HAS 98,000 ORIGINAL MILES ON IT! FORD FAILED TO PROVIDE ANY CORROSION PROTECTION ON THESE RANGER TRUCK FRAMES.

Apr 24, 2016

FIST SIZE AND MULTIPLE FINGER SIZE RUST HOLES IN FRAME. SPARE TIRE MOUNTS COMPLETELY RUSTED OFF.SPARE TIRE WAS HELD ON BY STEEL LINE. WHEN I WAS DRIVING DOWN THE HIGHWAY LEAF SPRING MOUNT ON DRIVER SIDE RUSTED COMPLETELY OFF. LEAF SPRING NOW PUSHES UP ON BOTTOM OF THE BED. ALSO HAPPENED WHILE DRIVING DOWN HIGHWAY HEARD A LOUD BANG. GOT HOME AND SEEN THAT IS WHAT HAPPENED. DRIVING THIS TRUCK PUTS ANYONE ON THE ROAD IN IMMEDIATE DANGER. DRIVER AND OTHERS. I WOULD SAY EVERYTHING THAT HAS HAPPENED WOULD BE "NEAR MISSES"

May 09, 2015

VEHICLE SPEED CONTROL

4 complaints

DRIVING HOME FROM WORK (1/4 COMMUTE FROM OFFICE TO HOUSE, THROUGH RESIDENTIAL NEIGHBORHOOD). MOVING ALONG STREET AT 25 MPH, APPROACH SLIGHT ROAD INCLINE & APPLY GAS APPROPRIATELY FOR CONDITIONS (DRY PAVED ROAD); VEHICLE SUDDENLY ACCELERATES VERY RAPIDLY, CAUSING REAR END TO FISHTAIL, VEHICLE PULLS LEFT; (STRIKES PARKED CAR AT END OF DRIVEWAY LEFT SIDE OF ROAD); APPLYING BRAKES WHILE ATTEMPTING TO GAIN CONTROL OF STEERING; BRAKES WILL NOT SLOW THE VEHICLE; STEERING OVER-CORRECTS TO RIGHT; (STRIKE PARKED CAR AT END OF DRIVEWAY RIGHT SIDE OF ROAD); VEHICLE CONTINUES ON AND STRIKES SIDE OF HOUSE. THROTTLE NOW RETURNS TO PROPER IDLE. SHUT DOWN VEHICLE, WHICH IS THEN TOWED FROM SEEN. BOTH AIR BAGS DEPLOYED. VEHICLE SEVERELY DAMAGED! *TR

Mar 31, 2015

Crash: 1

TL* THE CONTACT OWNS A 2005 FORD RANGER. WHILE DRIVING 40 MPH, THE CONTACT ATTEMPTED TO ACCELERATE AND NOTICED THAT THE VEHICLE HAD CONTINUED TO ACCELERATE ON ITS OWN. THE CONTACT HAD TO SHUT THE VEHICLE OFF IN ORDER TO STOP THE FAILURE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC, WHERE THE THROTTLE BODY WAS REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 20,000. THE VIN WAS NOT AVAILABLE.

Mar 13, 2012

INERTIA SWITCH CONTINUES TO FAIL UNDER NORMAL DRIVING CONDITIONS. I'VE HAD THIS SWITCH GO OFF SO MANY TIMES, I'M HESITANT TO CONTINUE DRIVING MY TRUCK! LAST NIGHT IT HAPPENED IN THE MIDDLE OF A CROWDED FREEWAY A LITTLE AFTER RUSH HOUR. I WAS ABLE TO MAKE IT OFF THE FREEWAY DUE TO AN OFFRAMP, BUT SINCE THE BRAKES WERE PRACTICALLY NON-EXISTENT I SLOWLY HIT INTO A CURB. THIS IS VERY FRUSTRATING! TRUCK COMPLETELY SHUTS OFF FOR NO REASON!!!! NOW THE SWITCH WON'T STAY OFF AND I GUESS I'LL NEED TO TAKE IT TO FORD. HOWEVER FROM READING ALL THE OTHER POSTS, NOT SURE WHAT GOOD THAT'LL DO. *TR

Oct 16, 2007

Crash: 1

MY 2005 FORD RANGER 4 CYLINDER 5 SPEED ACCELERATOR PEDAL STICKS REQUIRING MORE FOOT PRESSURE THAN NORMAL TO ACCELERATE AND MAKING ME OVER ACCELERATE TO GET THE CAR TO START MOVING. *NM

Nov 22, 2005

SERVICE BRAKES, HYDRAULIC

3 complaints

The contact owns a 2005 Ford Ranger. The contact received notification of NHTSA Campaign Number: 23V306000 (Air Bags) and requested to be removed from the recall distribution list because the vehicle was totaled. The local dealer was contacted. The manufacturer was not contacted.

Sep 12, 2023

TL* THE CONTACT OWNS A 2005 FORD RANGER. WHILE TRAVELING AT SPEEDS OF 5 MPH, THE CONTACT APPLIED THE BRAKES AND THE BRAKES WOULD NOT ENGAGE. IN ORDER TO BRING THE VEHICLE TO A STOP, THE CONTACT HAD TO SHUT OFF THE ENGINE, CAUSING THE BRAKES TO LOCK. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHERE THE BRAKE BOOSTER, ROTORS, AND FRONT DISC WERE REPLACED. THE FAILURE AND CURRENT MILEAGES WERE 46,000.

Apr 23, 2010

PROBLEMS WITH BRAKES ON 2003 THROUGH 2005 FORD RANGER PICKUP TRUCKS. I HAVE OWNED A BRAND NEW 2003 FORD RANGER EDGE STANDARD CAB PICKUP AND NOW OWN A 2005 FORD RANGER XLT EXTENDED CAB PICKUP. BOTH PICKUPS I HAVE HAD PROBLEMS WITH THE FRONT AND REAR BRAKES. THE 2003 FORD RANGER, THE READ BRAKE SHOE LININGS CAME DETACHED FROM THE SHOE CAUSING DAMAGE AND HAVING TO HAVE THE BRAKE COMPONENTS REINSTALLED AT MY COST. THE 2005 FORD RANGER HAS HAD THE SAME ISSUES BUT WITH HARDWARE FAILURE OF THE SPRINGS AND TENSIONERS. BOTH SITUATIONS THE BRAKES FAILED AND ARE NOT COVERED UNDER WARRANTY. THE 2003 FORD RANGER, I WAS SHOWN THE SHOES BY A SERVICE TECHNICIAN AND TOLD THE BRAKES WOULD HAVE LASTED AT LEAST UNTIL 50,000 MILES BUT THE "SALT" FROM NY WINTERS EATS AWAY THE GLUE THAT HOLDS THE SHOE LININGS TO THE SHOE AND CAUSES IT TO SEPARATE. I WAS TOLD THAT THE DEALERSHIP CONTINUES TO HAVE SEVERAL ISSUES WITH FORD BRAKES ON ALL MODELS DUE TO THE WINTER SEASON. IN BOTH CASES, I HAD MY BRAKES SERVICED THROUGH THE DEALERSHIP AND PAID TO HAVE THEM "CLEANED, INSPECTED, AND LUBRICATED" PER THE SERVICE MANUAL. I HAVE SPENT LARGE AMOUNTS OF MONEY WITH PROBLEMS ON MY BRAKES EVERY YEAR ON BOTH OF THESE VEHICLES THAT I OWNED. I NO LONGER OWN THE 2003 FORD RANGER BUT I CURRENTLY OWN THE 2005. IF THIS PROBLEM HAD HAPPENED DURING DRIVING, IT COULD HAVE CAUSED A SERIOUS ACCIDENT WITH A VERY LARGE SUM OF MONEY TO REPLACE BRAKES THAT CONTINUE TO BE PROBLEMS ON THIS MODEL. MOST OF MY DRIVING IS HIGHWAY AND VERY LITTLE OFF ROAD. THE PARTS IN THE BRAKES APPEAR TO BE OF LOW QUALITY AND OF MANUFACTURER DEFECT (GLUE NOT HOLDING, SPRINGS BREAKING, PARTS BREAKING UNDER NORMAL CONDITIONS). I THINK THERE IS SERIOUS PROBLEMS WITH THE BRAKE PARTS TO INCLUDE SPRINGS, TENSIONERS, PADS AND SHOES ON THE 2003 TO 2005 FORD RANGERS ENOUGH TO CAUSE SERIOUS DAMAGE OR LOSS OF LIFE DUE TO FAILURE OF COMPONENTS. *JB

Jul 30, 2007

ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

3 complaints

TL* THE CONTACT OWNS A 2005 FORD RANGER. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STOPPED IN THE MIDDLE OF TRAFFIC WITHOUT WARNING. THE VEHICLE WAS COASTED TO THE CONTACT'S RESIDENCE AND THE CONTACT REPLACED THE FUEL FILTER. THE FAILURE RECURRED AND THE CONTACT REPLACED THE FUEL PUMP. THE FAILURE RECURRED A THIRD TIME AND THE VEHICLE WAS TAKEN TO AN UNKNOWN INDEPENDENT MECHANIC WHO DIAGNOSED AND REPLACED THE INERTIA SWITCH. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS NOT PROVIDED.

Sep 29, 2017

AS A PASSENGER ENTERED MY TRUCK, THEIR FOOT HIT THE INERTIA SWITCH KILLING THE FUEL SYSTEM. THIS HAS NOW HAPPENED APPROXIMATELY 15 TIMES, 3 OF WHICH NO PASSENGER WAS EVEN IN THE TRUCK. THIS SWITCH IS PLACED IN A COMMONLY KICKED AREA AND ONCE TRIPPED THE FIRST TIME IT BECOMES EXTREMELY SENSITIVE TO VIBRATION. ONE TIME IT CUT OFF WHILE I WAS IDLING IN LINE AT A DRIVE-THRU. IT SHOULD BE RECALLED AND RELOCATED. *TR

Mar 06, 2013

MULTIPLE SHUT OFFS FROM THE INERTIA SWITCH HAS BEEN GOING ON FOR 2+ YEARS AFTER DRIVING FOR 30-40 MINS TRUCK WILL JUST SHUT DOWN WHILE DRIVING HAS HAPPENED ON THE INTERSTATE, DRIVING AROUND TOWN OR SITTING AT STOP LIGHT. ENDED UP MELTING THE CONNECTION. HAVE REPLACED. *TR

Nov 27, 2012

FUEL SYSTEM, OTHER,ELECTRICAL SYSTEM

3 complaints

THE FUEL INERTIA SWITCH WOULD MALFUNCTION FOR NO REASON. THE CAR WOULD JUST DIE, LOSING ALL POWER (MANY TIMES HAPPENING AT 65 MPH ON FREEWAY). IT HAPPENED AT LEAST 15 DIFFERENT TIMES. THE "RESET" BUTTON WOULD HAVE TO BE USED TO GET VEHICLE STARTED AGAIN. EVENTUALLY, THE COMPONENT "MELTED," AND HAD TO BE REPLACED. I WAS TOLD AT THE DEALERSHIP NOT TO LET THE FUEL LEVEL GET LOWER THAN 1/4 TANK, TO PREVENT THIS FROM HAPPENING AGAIN. VERY DANGEROUS ISSUE, WHICH FORD IS AWARE OF< BUT DOES NOTHING! *TR

Mar 14, 2011

Fire: 1

I WAS DRIVING 65MPH ON THE FREEWAY (WHICH WAS SMOOTH) AND MY INERTIA SWITCH WENT OUT. THIS SHUT OFF MY POWER STEERING, MY POWER BRAKES AND I WAS ALMOST KILLED BY A SEMI TRUCK BECAUSE OF THIS. IT HAPPENED 10 TIMES TODAY, USUALLY WHEN COMING TO A STOP. THIS HAS HAPPENED MULTIPLE TIMES, AND FORD HAS NOT YET ISSUED A RECALL. ABOUT TWO WEEKS AGO, THE SAME THING HAPPENED (ON THE FREEWAY), AND ONCE AGAIN ALMOST CAUSED AN ACCIDENT. THEY HAVE ALREADY TRIED FIXING THIS BEFORE AND IT CONTINUES TO OCCUR. I HAVE READ MULTIPLE INSTANCES OF THIS OCCURRING AND BELIEVE THIS IS AN EXTREMELY DANGEROUS DEFECT, AND ALMOST COST ME MY LIFE. I HAVE A 2005 FORD RANGER. THANK YOU FOR READING MY PROBLEM, I AM VERY DISTURBED BY THIS AND HOPE FORD WILL FIX THIS. *TR

Aug 15, 2010

INERTIA SWITCH TRIPPED IN 2008 WHILE PARKED!? WALKED HOME, LOOKED UP ON INTERNET, FOUND OUT HOW TO RESET. FEBRUARY 2010 THE INERTIA SWITCH TRIPPED AGAIN WHILE COASTING DOWN SMOOTH ROAD. PULLED OVER AND RESET SWITCH. DAUGHTER REPORTS INERTIA SWITCH TRIPPED A COUPLE OF WEEKS LATER, FORTUNATELY I TOLD HER HOW TO RESET IT. THIS COULD BE VERY DANGEROUS AND LIFE-THREATENING, ESPECIALLY IF IT HAPPENED ON A CROWDED FREEWAY! I FEEL THAT FORD KNOWS THIS IS A PROBLEM, HAVE CREATED A RELOCATION KIT. FOR A HUNDRED BUCKS! I FEEL FORD SHOULD PAY FOR IT. I HAVE ONLY 7K MILES ON THIS TRUCK, IN FIVE YEARS! *TR

Feb 24, 2010

FUEL SYSTEM, OTHER

3 complaints

I HAVE A 2005 RANGER TRUCK AND IT OCCASIONALLY FEELS LIKE IT IS RUNNING OUT OF GAS. I HAD MY MECHANIC CHECK ALL PHASES OF WHAT COULD BE WRONG AND HE FOUND NOTHING. I NEVER HEARD OF THE INERTIA SWITCH UNTIL READING ON HERE. I WILL MENTION THIS TO MY MECHANIC TODAY. THANKS FOR THE INFO. I DID NOT WRITE DOWN DATES AND TIMES. *TR

Jun 14, 2010

I HAVE A 2005 FORD RANGER 4 WHEEL DRIVE WHICH I PURCHASED NEW. ON A RECENT TRIP A TRAILER TRUCK CHANGED LANES ON THE PA TURNPIKE WITHIN FEET OF MY FRONT END. IN ORDER TO AVOID AN ACCIDENT I HIT THE BRAKES VERY HARD. THE INERTIA SWITCH STOPPED THE FUEL PUMP AND SOME HOW I WAS ABLE TO COAST ACROSS 2 LANES TO THE BERM. I CALLED THE FORD DEALER AND THEY SAID THAT THE GUARANTEE WAS 3 YEAR OR 36,00 MILES AND AT THE TIME I HAD ABOUT 37,500 MILES ON THE TRUCK AND WAS OBVIOUSLY OVER THE THREE YEARS. I HAD THE SWITCH REPAIRED AT A COST OF OVER $200.00. AFTER THE OCCURRENCE ABOVE THE SWITCH WENT OFF 5 TIMES DURING NORMAL DRIVING. I HAVE THE BAD SWITCH IN MY POSSESSION IF YOU ARE INTERESTED. THIS WAS A VERY SERIOUS SITUATION WHICH I THINK FORD SHOULD PAY FOR. LOOSING ALL POWER ON A SUPER HIGHWAY IS DANGEROUS TO SAY THE LEAST. *TR

Jul 14, 2009

WHEN TURNING LEFT ON INCLINE/DECLINE FUEL INERTIA CUTOFF SWITCH ACTIVATES LEAVING NO STEERING OR BRAKING ASSIST/POWER. *TR

Oct 24, 2008

SUSPENSION,STRUCTURE,UNKNOWN OR OTHER

2 complaints

THE UNDER CARRIAGE OF MY VEHICLE HAS A LOT OF RUST UNDERNEATH AND ON THE DORRS I HAVE SEEN A FEW COMPLAINTS NOT SURE IF THIS IS SAFE OR NOT

Jun 29, 2018

THE FRAME UNDER THE TRUCK ESPECIALLY THE REAR IS LITERALLY RUSTING AWAY. THE CROSS MEMBERS THAT HOLD THE FUEL TANK ARE SEVERELY RUSTED AND OVER HALFWAY GONE ON THE RIGHT SIDE OF THE VEHICLE.

Aug 12, 2017

SERVICE BRAKES

2 complaints

MALFUNCTION/FAILURE OF VEHICLE ABS UNIT. FAILURE OCCURRED INTERMITTENTLY AND THEN PERMANENTLY IN THE FALL/WINTER OF 2014. VEHICLE IS 10 YEARS OLD BUT HAD LESS THAN 30 THOUSAND MILES, AND HAS BEEN GARAGED FOR ITS ENTIRE OPERATIONAL LIFE. IT TOOK SEVERAL MONTHS FOR INDEPENDENT MECHANIC TO BE ABLE TO ACQUIRE NEW OEM ABS UNIT, IMPLYING THAT MANY OTHER VEHICLES ARE EXPERIENCING THIS UNIT FAILURE. NARROWLY AVOIDED SEVERAL ACCIDENTS DUE TO BRAKES LOCKING UP DURING EMERGENCY BRAKING. RECEIPT FOR REPAIR IS ATTACHED.

Oct 04, 2015

WHEN APPLING BRAKES, JUST BEFORE YOU COME TO A STOP THE BRAKES MAKE A NOISE AND THE BRAKE PEDAL SPONGES AT THE END OF THE STOP, PULLING TO THE RIGHT. *TR

Aug 21, 2014

STEERING

2 complaints

TL* THE CONTACT OWNS A 2005 FORD RANGER. THE CONTACT STATED THAT THERE WAS AN ABNORMAL NOISE COMING FROM THE STEERING WHEEL WHEN MAKING LEFT OR RIGHT TURNS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN THE MANUFACTURER'S RECALL RELATED TO THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

Aug 03, 2015

TL*THE CONTACT OWNS A 2005 FORD RANGER. THE CONTACT STATED THAT THE TIE ROD WAS WEARING. HE ALSO HEARD A LOUD CLANGING NOISE WHILE DRIVING VARIOUS SPEEDS. THE DEALER LUBRICATED THE TIE ROD, BUT THE FAILURE CONTINUED. THE NOISE HAS GOTTEN WORSE AND FORD REFUSES TO ASSIST. THE FAILURE MILEAGE WAS 6,000 AND CURRENT MILEAGE WAS 7,200.

May 28, 2009

EXTERIOR LIGHTING

2 complaints

TL* THE CONTACT OWNS A 2005 FORD RANGER. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE PASSENGER SIDE TURN SIGNAL FAILED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE STEERING COLUMN MULTI FUNCTION SWITCH WOULD NEED TO BE REPLACED. THE CONTACT WAS INFORMED OF A RECALL FOR NHTSA CAMPAIGN NUMBER: 11V352000 (EXTERIOR LIGHTING). THE MANUFACTURER WAS NOTIFIED BUT STATED THE VIN WAS NOT PART OF THE RECALL. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 65,000 AND THE CURRENT MILEAGE WAS 70,000.

Apr 16, 2013

HEADLAMP SWITCH KNOB BREAKS AND FALLS OFF. 2ND REPLACEMENT IN 2005 FORD RANGER WITH 8000 MILES. WITHOUT KNOB, IMPOSSIBLE TO TURN HEADLAMPS ON AND OFF WITHOUT PLIERS. HAD TO BUY NEW SWITCH KNOBS.

Mar 19, 2007

ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE

2 complaints

THE VEHICLE WILL SHUT DOWN AND YOU LOSE TOTAL CONTROL. POWER STEERING GONE. ENGINE GONE. IT WILL HAPPEN AT ANY TIME. THE REASON IT IS SO DANGEROUS IS BECAUSE I HAVE HAD IT SHUT DOWN ON THE FREEWAY GOING 65MPH. I WAS LUCKY ENOUGH NEVER TO HAVE GOTTEN HIT BUT IT WAS A CLOSE CALL. 1. THE VEHICLE WOULD JUST STALL LIKE IT WAS RUNNING OUT OF GAS. 2. WHEN THE PART WAS GOING BAD IT WOULD OCCUR EVERY DAY. WHEN THE PART WAS TOTALLY MALFUNCTIONING IT WOULD NOT EVEN START. 3. THE FIRST TIME I HAD THE DEALER REPLACE THE PART VIA THE WARRANTY. THE SECOND TIME I PAID TO HAVE IT REPLACED. THE THIRD TIME I REPLACED IT MYSELF. IT LASTS ABOUT A YEAR THEN IT GOES BAD. *TR

Sep 18, 2010

PURCHASE VEHICLE JULY 2005, VEHICLE NEVER HAD A GOOD PULL TO IT AND I THOUGHT IT WAS THE WAY THE TRUCK JUST PULLED UNTIL MAY 2006 WHEN I WAS HIT FROM BEHIND BY A FORD EXPLORER, MY TRUCK GOT WORSE. IN JUNE 2007 ENGINE LIGHT CAME ON WOULDN'T GO OFF. GAS CAP LIGHT CAME ON WOULDN'T GO OFF. TRIED TO TIGHTEN CAP, LIGHTS STILL HAVEN'T WENT OFF. TOOK TRUCK TO MECHANIC FOUND OUT THAT MY TRUCK HAD A CRACKED HEAD THAT WAS INDICATED THAT IT COULD HAVE BEEN A DEFECT FROM THE MANUFACTURE AND OR POSSIBLY DUE TO COLLISION ALSO FORD MANUFACTURE HAD A DEFECT CALL BACK ON ALL 2005 FORD RANGER. IN DECEMBER 2005 FIVE MONTH AFTER I PURCHASE THE TRUCK AND THEY ( FORD) DID NOT EVEN NOTIFY ME OF THE DEFECT. I DO HAVE A COPY IN MY POSSESSION FROM MY MECHANIC. ALSO I WAS TOLD THAT MY TRUCK COULD IGNITE AND CATCH A FIRE AT ANY TIME. *TR. UPDATED 01/11/08.*LJ THERE WAS A CRACKED HEAD ON THE FUEL SENDING UNIT. UPDATED

Oct 05, 2007

Crash: 1

Injuries: 2

SEATS

2 complaints

I OWN A 2005 2 DOOR FORD RANGER XLT. WITH APPROXIMATELY 29,000 TOTAL MILES. IT IS SUPPOSED TO BE COVERED UNDER THE NEW CAR WARRANTY UNTIL AUGUST 2008 OR 30,000 TOTAL MILES. PROBLEM: THE PASSENGER SIDE SEAT BACK OCCASIONALLY STICKS IN THE FULL UPRIGHT OR RECLINED POSITION WHEN THE SEAT BACK RELEASE LEVER IS PULLED UP, (ACTIVATED). IT TAKES UP TO SEVERAL MINUTES OF JIGGLING THE BACK AND RELEASE LEVER TO GET THE BACK TO SWING FORWARD. ALSO THE RELEASE LEVER HAS BEEN FOUND TO STICK IN A POSITION THAT WON'T ALLOW THE BACK TO MOVE. OUR GRANDSONS HAVE BEEN RIDING IN BACK AT TIMES, (UNTIL I REALIZED THE POTENTIAL DANGER OF NOT ALLOWING THEM TO EXIT IN A HURRY). I HAVE TAKEN THE TRUCK TO THE LOCAL DEALER, (I WILL GO THERE TOMORROW FOR THE FORTH TIME) TO HAVE THE MECHANISM FIXED OR THE SEAT REPLACED. THE DEALER STATES THAT THEY CANNOT FIX THE PROBLEM UNLESS IT OCCURS WHEN THEY ARE WORKING ON THE TRUCK. THE PROBLEM FIRST APPEARED ABOUT A YEAR AGO, I BELIEVE. I HAVE INFORMED THE DEALER, VERBALLY, OF THE POTENTIAL DANGER, BUT THEY APPEAR TO BE ADVERSE TO MAKING A CORRECTION. I COULD FIND NO RECALL NOTICE OR OTHER INFORMATION OF SIMILAR PROBLEMS WITH TWO OLDER RANGERS I OWNED IN THE PAST. *TR

Jul 16, 2008

DT*: THE CONTACT STATED WHILE DRIVING 2 MPH IN REVERSE, THE VEHICLE NEARLY STRUCK A PEDESTRIAN DUE TO THE SEAT BACKS OF BOTH THE DRIVER AND PASSENGER SEATS BLOCKING OUT MOST OF THE VISIBILITY THROUGH THE REAR WINDOW. A SERVICE DEALER WAS CONSULTED, WHO INSTRUCTED THE CONTACT TO CONTACT THE MANUFACTURER.

Aug 29, 2006

PARKING BRAKE,POWER TRAIN

1 complaint

The contact owns a 2005 Ford Ranger. The contact stated that upon arriving to the residence and applying the parking brake and exiting the vehicle, the vehicle started to roll backwards. The contact stated that the vehicle came to a complete stop after rolling across the street and through the neighbor’s fence. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 223,000. The VIN was not available.

Feb 04, 2025

AIR BAGS,VEHICLE SPEED CONTROL,UNKNOWN OR OTHER

1 complaint

At 200k miles I got an air bag light on my guage cluster. The blinking code corresponded to a bad connection at the CLOCKSPRING. I also noticed my cruise control and horn were also inoperable, also an indicator of a bad CLOCKSPRING. Ford part number 1l5z-14a664-ab is the replacement part and is currently unavailable, for the last 6 months. This part covers a few different models and has been exhausted by the dealers when correcting the Airbag recall. The dealer can not give me a date on a replacement part.

Feb 13, 2023

VEHICLE SPEED CONTROL,SERVICE BRAKES,ENGINE

1 complaint

Incident was reported to me by an employee. Driving in traffic on a highway with normal, dry road conditions the accelerator pedal started moving down on its own. The truck accelerated on its own from 50 mph to 70+ mph. Applying the brakes the truck did NOT slow down. Eventually, the accelerator pedal corrected itself and started working normally. There was no indication on the dashboard of the issue. This could have resulted in a serious accident or death. The truck is waiting to be towed to the Ford garage for repair. Thank you, Wendy McNeill

Dec 10, 2021

TRACTION CONTROL SYSTEM

1 complaint

TL* THE CONTACT OWNS A 2005 FORD RANGER. WHILE DRIVING 5 MPH, THE CONTACT LOST CONTROL OF THE VEHICLE. THE VEHICLE DROVE OVER AN ICY PATCH, SLID, AND CRASHED INTO ANOTHER VEHICLE. THE AIR BAGS DEPLOYED. THE CONTACT SUSTAINED A STOMACH INJURY, BUT DID NOT RECEIVE MEDICAL ATTENTION. THE OTHER DRIVER SUSTAINED AN INJURED BACK. THE CONTACT DID NOT KNOW IF THE OTHER DRIVER SOUGHT MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE CONTACT'S VEHICLE WAS NOT DAMAGED AND WAS DRIVEN TO THE CONTACT'S HOME. THE VEHICLE WAS LATER TAKEN TO COURTESY FORD LINCOLN (313 NE 122ND AVE, PORTLAND, OR 97230), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 200,043. THE VIN WAS UNKNOWN.

May 16, 2019

Crash: 1

Injuries: 2

ELECTRICAL SYSTEM,AIR BAGS

1 complaint

I HAD THE AIR BAGS REPLACED, AFTER NEW AIRBAGS WERE INSTALLED. AIR BAG WARNING LIGHT WAS FLASHING, CODE 27, WHICH MEANS PASSENGER AIR BAG BYPASS MODULE # F81B-14BZ68-AD. MODULE HAD A BAD INDICATOR LAMP WHICH IN TURNS DISABLES THE ENTIRE AIR BAG SYSTEM. SO IN MY OPINION FORD SHOULD REPAIR THIS SO THAT I CAN HAVE AIR BAGS TO PROTECT ME. WITH THIS LAMP NOT FIXED I HAVE NO AIR BAGS, SO THE RECALL WAS USELESS. I NEED THIS FIXED AND THINK IT SHOULD BE CONSIDERED A SAFETY ISSUE ALONG WITH THE AIR BAG RECALL. I SPOKE TO FORD AND THEY INFORMED ME THAT IT WAS OR MAYBE IS AN ISSUE, NO COMMITMENT THERE. I CANNOT AFFORD THE INSPECTION COSTS BUT YOU TUBE GAVE ME ALL THE INFORMATION I NEED TO KNOW, THE $89 FOR INSPECTION AND $125. FOR PARTS AND INSTALLATION ARE WAY OUT OF MY BUDGET. THIS IS A SAFETY MATTER THAT NEEDS TO BE ADDRESSED. YES THIS IS A CONSTANT CONDITION TO THE FORD RANGER AS IT SITES NOW. THE YOU TUBE SITE I USED IS: WWW,YOUTUBE.COM/WATCH?V=U5MAYZJCTM, SO ANYONE CAN DIAGNOSIS MY TRUCK. DON'T NEED $89.00

May 10, 2019

VEHICLE SPEED CONTROL,FUEL/PROPULSION SYSTEM

1 complaint

TL* THE CONTACT OWNS A 2005 FORD RANGER. WHILE DRIVING, THE ACCELERATOR PEDAL BECAME STUCK. IN ORDER TO CORRECT THE FAILURE, THE VEHICLE WAS SHIFTED INTO NEUTRAL AS THE ACCELERATOR PEDAL WAS DEPRESSED. THE CONTACT STATED THAT THE FAILURE OCCURRED INTERMITTENTLY. THE DEALER AND MANUFACTURER HAD NOT BEEN CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 245,000. *TT CONSUMER STATED WHEN GIVING VEHICLE FALL OPEN THROTTLE, THROTTLE PEDDLE STICKS AND THERE IS NO CONTROL OF SPEED. UPDATED 10/17/18*JB

Aug 06, 2018

AIR BAGS,UNKNOWN OR OTHER

1 complaint

"TAKATA RECALL " WHELL I AM LUCKY NOTHING VERY SERIOUS HAS HAPPENED WITH THESE RECALLED AIRBAGS. THANK YOU FOR TAKING YOUR TIME AND BY LETTING ME KNOW ABOUT THE AIRBAGS

Nov 14, 2017

STEERING,SUSPENSION,UNKNOWN OR OTHER

1 complaint

DUE TO EXTENSIVE RUST DAMAGE DESPITE PROPER PREVENTATIVE MAINTENANCE, THE INTEGRITY OF THE FRAME/CHASSIS OF THE VEHICLE WAS COMPROMISED. SUBSEQUENTLY, THE LEFT SIDE OF THE FRAME AT THE MIDWAY POINT OF THE LENGTH OF THE VEHICLE SNAPPED COMPLETELY SEPARATING INTO TWO PIECES. THE RUST DAMAGE ALSO CAUSED THE SPARE TIRE APPARATUS TO BREAK AND ALSO CAUSED THE BUMPER TO FALL OFF.

Jan 23, 2017

SUSPENSION,WHEELS

1 complaint

L/FRONT SUSPENSION SNAPT FROM THE FRAME (THE FRAME BROCK).

Aug 19, 2015

WHEELS,UNKNOWN OR OTHER

1 complaint

ENTIRE SPARE TIRE STORAGE MOUNT ASSEMBLY BROKE FREE FROM FRAME AND PULLED WIRES AND HOSES WITH IT AS IT WENT UNDER MY RIGHT TIRE AND CAUSED ME TO GO OFF ROAD NEARLY CRASHING INT TREES

Jun 07, 2015

POWER TRAIN,ENGINE

1 complaint

AT STARTUP MY CHECK ENGINE LIGHT CAME ON AND AS I WENT TO DRIVE AWAY THE ENTIRE TRUCK STARTED SHAKING AND THE CHECK ENGINE LIGHT STARTED TO FLASH.I TRIED TO FIX THE VEHICLE WITH A SCAN TOOL AND STARTED REPLACING THE LESS EXPENSIVE PARTS AND WHEN IT WAS ALL SAID AND DONE IT TURNED OUT TO BE THE DRIVER SIDE CYLINDER HEAD NUMBER FOUR AND SIX CYLINDER THEY BOTH HAD RECESSED VALVES.BEFORE THE TRUCK GOT REAL BAD I WAS ON THE INTERSTATE GOING TO BE A SLIGHT INCLINE AND THE TRUCK WAS DOING 75 MILES AN HOUR AND THEN SUDDENLY DROPPED TO MAYBE 15 20 MILES AN HOUR ALMOST CAUSING AN ACCIDENT ON INTERSTATE 10 I HAD TO IMMEDIATELY PULL OFF THE SHOULDER OF THE ROAD TO AVOID GETTING REAR ENDED.I JUST RECENTLY REPLACED THE THIRD SET OF HEADS ON THE SAME VEHICLE SAME SIDE SAME CYLINDERS AND I'M BEING TOLD NOW THAT THEY THINK ITS THE CATALYTIC CONVERTERS I REALLY DON'T KNOW I LIKE MY TRUCK BUT THIS IS GETTING RIDICULOUS.I'VE CALLED FORD DIRECTLY TOLD THEM WHAT'S BEEN GOING ON AND THEY SAID MY TRUCK DOES NOT FALL UNDER THE CAMPAIGN BULLETINS AND THAT I WILL HAVE TO REPLACE MY HEAD'S EVERY 42000 MILES. *TR

Jan 20, 2015

SUSPENSION,STRUCTURE,SERVICE BRAKES

1 complaint

I HAVE A 2005 FORD RANGER EXTENDED CAB. I WAS DRIVING IT AND I NOTICED THAT MY BRAKES FELT REALLY FUNNY SO I BROUGHT IT TO MY MECHANIC AND HE TOLD ME THAT THE BRAKE LINES WERE ROTTED OUT, BUT MORE IMPORTANTLY THAT THE FRAME WAS ROTTED OUT. THE BODY MOUNTS ARE ROTTED OUT, THE SHACKLES ARE ABOUT TO FALL OFF. HE ALSO SAID THAT THE FRAME RAILS IN BETWEEN THE LEAF SPRINGS ARE ABOUT TO BREAK IN HALF, AND IF THIS HAPPENED TO ME WHILE I WAS DRIVING I COULD HAVE KILLED SOMEONE OR MYSELF. I AM VERY CONCERNED ABOUT MY SAFETY AND THE SAFETY OF EVERYBODY ELSE DRIVING A FORD RANGER THAT IS NOT AWARE IF ITS ISSUE. I AM ALSO NOW STUCK WITH A TRUCK THAT NEEDS WORK DONE THAT WILL COST TWICE AS MUCH AS IT IS WORTH. *TR

Sep 07, 2014

SUSPENSION,STRUCTURE,TIRES,WHEELS

1 complaint

UNDER- BED MOUNTED SPARE TIRE MOUNTS RUSTED THROUGH CAUSING TIRE TO BREAK FREE FROM VEHICLE AT HIGHWAY SPEEDS. UPON FURTHER INSPECTION IT WAS NOTED VEHICLE HAS SERIOUS FRAME DAMAGE FROM RUST, PARTICULARLY THE FUEL TANK SUPPORT STRAPS. THE FRAME IS FALLING APART AT AN ALARMING RATE. *TR

Aug 08, 2014

SUSPENSION,AIR BAGS,STRUCTURE

1 complaint

MY HUSBAND T-BONED A SEMI AT 35 MPH. THE TRUCK SPUN AROUND AND THE REAR OF THE TRUCK ALSO HIT THE SEMI. THE AIRBAGS DID NOT DEPLOY. HE INCURRED MULTIPLE INJURIES, SOME OF WHICH COULD HAVE BEEN MINIMIZED HAD AIRBAGS DEPLOYED. THE TRUCK WAS TOTALED. THERE WAS A DIRECT HIT -- I.E. FRONT OF TRUCK HIT SIDE OF SEMI AND DESTROYED ENGINE (AND MORE), YET AIR BAG DID NOT DEPLOY. . *TR

Jul 21, 2014

Crash: 1

Injuries: 1

STRUCTURE,SERVICE BRAKES

1 complaint

TL* THE CONTACT OWNS A 2005 FORD RANGER. THE CONTACT STATED THAT WHILE HAVING ROUTINE MAINTENANCE PERFORMED ON THE VEHICLE, THE TECHNICIAN NOTIFIED HIM THAT THE FRAME WAS COMPLETELY CORRODED. IN ADDITION, THE TECHNICIAN STATED THAT THE CORROSION WAS CAUSING THE BRAKES TO FAIL. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 56,000.

Oct 30, 2013

ELECTRICAL SYSTEM,SERVICE BRAKES

1 complaint

ELECTRIC FUEL INERTIA KILL SWITCH MALFUNCTION(OVER HEATING AND CAUSING ENG> SHUTDOWN WHILE DRIVING!) EXTREMELY DANGEROUS!! *TR

Jun 07, 2013

STEERING,SUSPENSION,STRUCTURE

1 complaint

HIT A PARKED VAN. *TR

Jan 16, 2013

Crash: 1

FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM,UNKNOWN OR OTHER

1 complaint

TWO TIMES IN 2 DAYS I WAS DRIVING WHEN THE VEHICLE SUDDENLY STALLED/SHUTOFF. FORTUNATELY BOTH TIMES I WAS ABLE TO PULL OVER OUT OF TRAFFIC. IT FELT LIKE MY PEDAL WENT DEAD, I LOST MY POWER STEERING AS WELL. SINCE I WAS ABLE TO CONNECT TO THE INTERNET THROUGH MY PHONE I WAS ABLE TO SEARCH "FORD RANGER SUDDENLY DIES WHILE DRIVING." AN OVERWHELMING AMOUNT OF RESULTS INDICATED TO RESET MY INERTIA FUEL SHUTOFF SWITCH. I FOUND IT, RESET IT AND THE TRUCK STARTED AGAIN. AFTER THE SECOND TIME THIS HAPPENED I RESEARCHED FORD RANGER RECALLS, ONLY TO FIND THIS WAS NOT ONE OF THEM. I FEEL VERY APPREHENSIVE ABOUT DRIVING MY TRUCK, NOT KNOWING WHY IT SUDDENLY DECIDES TO TRIP THE FUEL SHUTOFF SWITCH. THIS IS EXTREMELY DANGEROUS AND IT NEEDS TO BE RECALLED.

Feb 13, 2011

ENGINE AND ENGINE COOLING,FUEL SYSTEM, OTHER

1 complaint

MY FORD RANGER (2005) LOST POWER GOING DOWN THE FREEWAY. AFTER MUCH INVESTIGATION, TIME, SAFETY ISSUES (QUITTING AT 55 + MPH) AND MONEY IT TURNED OUT TO BE THE INERTIA SWITCH. *TR

Jul 04, 2010

ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM

1 complaint

TL*THE CONTACT OWNS A 2005 FORD RANGER. THE CONTACT SMELLED PLASTIC BURNING IN THE ENGINE. HE TOOK THE VEHICLE TO THE DEALER WHO ADVISED HIM THAT HE NEEDED TO REPLACE THE ALTERNATOR AT HIS EXPENSE. THE MANUFACTURER STATED THAT THEY WERE UNABLE TO OFFER HIM ANY ASSISTANCE. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CURRENT MILEAGE WAS APPROXIMATELY 50,000. THE FAILURE MILEAGE WAS APPROXIMATELY 38,000. UPDATED 02/26/10 *BF UPDATED 06/14/10.*JB

Feb 11, 2010

TIRES,WHEELS

1 complaint

A TIRE VALVE STEM, # DILL 414, WAS LEAKING AIR AROUND THE BASE. THIS VALVE STEM CAME ON A BRAND NEW 2005 FORD RANGER, PURCHASED IN JULY OF 2005, WHICH IS PRIOR TO THE PRESENT RECALL PERIOD. *TR

Sep 14, 2008

VISIBILITY

1 complaint

TL*THE CONTACT OWNS A 2005 FORD RANGER. WHEN IT RAINS, WATER ENTERS THE MOTOR AND FREEZES THE WINDSHIELD WIPERS, RENDERING THEM INOPERABLE. THE VEHICLE IS UNDER WARRANTY UNTIL MARCH OF 2008, BUT THE WINDSHIELD WIPER MOTOR IS NOT. THE COST TO REPAIR THE MOTOR IS $105.04. THE CURRENT MILEAGE WAS 19,000 AND FAILURE MILEAGE WAS 18,574. UPDATED 02/15/08. *LJ

Jan 22, 2008

ENGINE AND ENGINE COOLING,POWER TRAIN

1 complaint

I AM THE OWNER OF A 2005 FORD RANGER THERE WAS A PROBLEM WITH THE TRANSMISSION. IT WAS TAKEN TO THE DEALER AFTER APPROXIMATELY 5 DAYS WE WERE ABLE TO PICK THE FORD UP AND THE TRANSMISSION WAS REPLACED. SHORTLY AFTER THIS THE VEHICLE STARTED TO SHUT DOWN WHILE DRIVING FOR NO APPARENT REASON .DURING ONE OF THESE TIMES IT SHUT DOWN I WAS REAR ENDED,IT WAS TAKEN BACK TO THE DEALER WAS THERE FOR 3 DAYS, AND THEY SAID THERE WAS NOTHING WRONG WITH THE VEHICLE AS THEY COULD NOT DUPLICATE THE PROBLEM THE DEALER INFORMED ME THE VEHICLE HAD NO PROBLEMS, AND WAS VERY SAFE TO DRIVE. ALSO, I CONTACTED FORD , AND WAS INFORMED THERE HAVE BEEN NO OTHER COMPLAINTS OF THE 2005 FORD RANGER JUST SHUTTING DOWN. THIS VEHICLE WAS FAR FROM SAFE NOT ONLY FOR THE DRIVER AND ANY PASSENGERS BUT ALSO FOR OTHER DRIVERS ON THE ROAD. AS IT JUST SHUT OFF WHEN IT WANTEDF. *AK

Jun 26, 2007

Crash: 1

Injuries: 2

STEERING,SUSPENSION

1 complaint

DT*: THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THERE WAS A CLUNKING NOISE COMING FROM THE FRONT SUSPENSION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP FOR INSPECTION. THE DEALER REPLACED THE TIE ROD ASSEMBLY AND UPPER CONTROL ARM BUSHINGS HOWEVER, THE PROBLEM PERSISTED.

Mar 20, 2006

SEAT BELTS

1 complaint

REAR PASSENGER SAFETY RESTRAINTS ARE NOT ADEQUATE TO PREVENT INJURY OF PASSENGERS. PASSENGERS BUMP THEIR HEADS ON REAR WINDOW IF DRIVER MUST BRAKE QUICKLY OR ACCELERATE RAPIDLY. SO FAR ONLY MILD INJURY, BUT CANNOT USE THE VEHICLE FOR CARRYING THREE OR MORE PASSENGERS AS WAS THE INTENT WHEN TRUCK WAS PURCHASED. *AK

Jan 26, 2006

Injuries: 2

FUEL SYSTEM, OTHER,POWER TRAIN

1 complaint

3 TIMES GOING DOWN THE ROAD THE TRUCK DIED AND HAD TO BE TOWED. ALL 3 TIMES WAS THE INERTIA SWITCH. THE OTHER TIME THEY REPLACED PART OF THE TRANSMISSION. ALL THIS ON A NEW TRUCK I'VE HAD FOR 6 WEEKS. THE TRUCK ISN'T SAFE. GO OUT INTO HEAVY INTERSTATE TRAFFIC GOING 65 AND SHUT YOUR VEHICLE OFF. IT ISN'T GOOD. THEY WANT ME TO TRY IT AGAIN. I CAN'T PUT MY FAMILY OR MYSELF IN THAT POSITION AGAIN.

Jun 30, 2005

2005 FORD Ranger Problems & Complaints

Complaints by Component

Frequently Asked Questions

How many problems does the 2005 FORD Ranger have?

What are the most common problems with 2005 FORD Ranger?

Where does this 2005 FORD Ranger problem data come from?

Other Years - FORD Ranger

Other FORD Models

Similar Brands