2019 FORD Ranger Problems & Complaints
Real owner complaints and problems reported to the National Highway Traffic Safety Administration (NHTSA). View common issues by component.
VIN Decoder
237
Complaints Reported
As an Amazon Associate, ForCar.org earns from qualifying purchases.
Complaints by Component
POWER TRAIN
62 complaints
The transmission stutters at sustained modest speed (25-45 mph). It was taken to the dealer, who determined it was affected by tsb 25-2134. This is a widely known issue and the dealer refused any servicing without payment. This should have been a recall, since hundreds of known issues in and out of warranty have occurred.
Jan 09, 2026
The automatic transmission and related transmission control system malfunctioned. The vehicle experienced improper shifting and loss of gears, including a condition in which 4th gear is disabled due to a failsafe logic triggered by the transmission control module. The vehicle and all affected components are currently available for inspection upon request and are at a Ford-authorized dealership. This malfunction posed a safety risk because the vehicle was unable to shift normally or maintain consistent acceleration. The unpredictable shifting and loss of gears could create hazardous situations when merging, accelerating, or driving at highway speeds, potentially endangering the driver and others. The problem has been reproduced and confirmed by a Ford dealership. After inspection and diagnostic testing, the dealership advised that the transmission requires replacement. The vehicle has been inspected by a Ford-authorized dealer. It has not been inspected by the manufacturer directly, police, or insurance representatives (UNKNOWN). Prior to the failure, warning messages and drivability symptoms were present. Specifically, the transmission control module detected an issue when attempting to shift into 4th gear, triggering a failsafe mode that disabled 4th gear for the remainder of the key cycle. These symptoms appeared before the full transmission failure and progressively worsened over time.
Jan 02, 2026
Transmission shifting issues. Will shift out of gear or delay shifting several seconds and sometimes limited power. The 1080r 10 speed transmission has a know design flaw that was finally fixed in 2023. My 2019 is now having the issue and is $8000 to fix for a bushing that moves out of place
Dec 11, 2025
I have had my 2019 Ford Ranger in for service to address issues with the transmission on 3 different occasions starting in Fall of 2023. Each time paying $106 for the deductible on the warranty to service a "Technical Service Bulletin" (TSB). Each time, being told of a different TSB that they would be addressing. Never addressing them all at the same time. In May of 2025, still experiencing the same/similar issues, I brought in in again only to be told that there was a TSB that they did not service, that my warranty had expired. Upon searching the internet, there are many people reporting similar issues with a similar response from Ford. I have spoken to multiple dealerships as well as reached out to Ford car with little to no response.
Dec 06, 2025
I’ve been noticing a delay in shit out of 1st, 3rd, 6th, and 9th gear. Sometimes it slams but most of the time not. Anyways, this morning on my way to work I passed a slow driver on 2 lane road. After I merged back into the lane, I resumed cruise control and basically lost all power to the wheels. The vehicle I passed about slammed into the back of me. I canceled cruise control to give gas and the transmission was fighting me to stay in a gear. It finally caught and I drove it the rest of the way to work with the “normal” 1,3,6,and 9 being weird. My safety and the other vehicles safety was definitely at risk. The was no warning lights that came on. I haven’t had it checked out yet because this is same day
Nov 26, 2025
+ 57 more complaints for this component
ELECTRICAL SYSTEM
16 complaints
The contact owns a 2019 Ford Ranger. The contact stated while driving approximately 10-15 MPH into the driveway at the residence, the vehicle lost electrical power and the vehicle shutoff as if there was no fuel going to the engine. The contact stated that there also a message that the rearview camera was inoperable, along with messages that features inside the cabin of the vehicle was inoperable. The contact restarted the vehicle and the vehicle shutoff immediately. The contact stated that the engine was not receiving fuel because the fuel pump was on the wiring harness that was not operating as needed. The contact stated that the messages “Cross Traffic Sensor Disconnected", “Rear Parking Sensor Disconnected” and "Rearview Camera Disconnected" were displayed on the instrument panel. The vehicle was taken to a dealer where it was diagnosed and determined that the electrical connector to the camera was corroded and not properly seated. The contact was informed that Part Numbers: LUTZ-14X411-NA and LUTZ-14X411-AAA needed to be replaced. The contact researched and became aware of a recall; however, the VIN was not included. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 65,064.
Apr 04, 2025
I have a 2019 Ford ranger that was built June 24th 2019 the internet states that any Ford ranger 2019 XLT built before July 30th 2019 has a recall for the HVAC system in the blower motor well my truck did not make the recall list but yet it has every single issue that they recall every time I call all they say is my vehicle VIN number is not on the recall but what is the chances that my blower motor and my blend door actuator does not work. When I bought the truck in 2021 I heard a ticking noise but the air still worked me being a female never thought much of it I thought it was my radio or something so this problem has existed since the day I bought it with 20,000 miles on it from the dealership. it has been tested by the Ford motor company and it does not work I have the same symptoms same issues and I should have my truck in the recall to get my air conditioner fixed it is a 4 year old truck and should not be broken I have on the truck for 4 years I bought it at 20,000 miles there's a ticking behind the dash and the blower motor does not work. I am disabled and live in South Carolina where is over 100° so it is a safety issue my truck should be on the recall the dealer should fix it how do I get this taken care of
Jul 15, 2024
The contact owns a 2019 Ford Ranger. The contact stated that while driving at various speeds, the lights on the instrument panel became inoperable, causing the vehicle to lose power. The contact stated that the messages “Unsafe Driving” and “Head-on Collision" were displayed. The contact waited until the engine cooled down before restarting and driving the vehicle. The contact stated that the vehicle also experienced a failure with A/C unit, and the failures became more persistent. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 42,000.
Jul 08, 2024
There's something wrong with the heater motor or the heater itself. When the heat is on even at the lowest setting the heat is too high. It gets very hot in the vehicle and I have to turn the heat off. The vehicle will fog up when the heater is turned off. There's also a smell like something's burning or overheating and there are clicking noises coming from behind the radio/ heater area. Also If the AC is turned on only the passenger side gets cold, and the driver side blows very hot air. The heat is on even in AC mode, very frustrating.
Apr 22, 2024
The contact owns a 2019 Ford Ranger. The contact stated while driving at an undisclosed speed, the air conditioner was activated. The air conditioner made a ticking sound. In addition, the A/C started blowing out hot air. The contact stated that the failure occurred when the temperature was 100 degrees. The contact stated that because of health issues, the air conditioner was required during the heated temperatures. The vehicle was taken to an independent mechanic where it was diagnosed with a failed A/C blower motor. The contact was informed that the A/C blower motor needed to be replaced. The vehicle was not repaired. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 120,000.
Apr 15, 2024
+ 11 more complaints for this component
UNKNOWN OR OTHER
13 complaints
2019 ford ranger, 74,000 miles On way to pick up girlfriends engagement ring…. The truck started jerking, loosing power, no engine light came on. Turned around to go home and drive about 8 miles under 45 mph.Then truck started jerking again , like transmission issue. Engine light and tool wrench came on. As I was pulling in driveway, truck went into “limp” mode. Had it towed to Gullo Ford Conroe. Now they are saying need new transmission due to Internal transmission failure! Shouldn’t Ford. Over this! Only 60,000 mile warranty.
Dec 22, 2025
Repeated failure of HVAC system, even after repairs, leads to not only a very cold truck in January in Maine, but inability to defrost the windshield and keep it defrosted. Repairs have been made in January 2025, April 2025, and now has to be repaired again in December 2025. My independent service provider who subscribes to OEM Ford subscriptions, was not made aware of an "internal" service memo until now. Neither from the subscription services or from contacts at a Ford dealer where he resourced parts and repair info. SSM 51313 indicates a different repair than was made on the previous two attempts. These repairs require the disassembly and reassembly of the instrument panel and are very expensive - especially when not apprised of correct. Now the SSM indicates a complete housing replacement to correct the defective part. See attached forms.
Dec 05, 2025
The transmission in my truck has worked excellently with no sign of wear or degredation in performance, that was until the transmission suddenly began hesitating and slamming into gear. This is a common problem with this vehicle and is reported online incredibly frequently, while this may seem like a simple mechanical issue it did cause a completely lost of power when making a left hand turn which nearly caused me to be T-bone'd by oncoming traffic, and the hard shifting makes throttle response incredibly unpredictable. Please help us with this, there are recalls on the transmission in these trucks in multiple other countries with the chance of death as a consequence being openly stated. Me and my loved ones were almost killed because of this transmission which has widespread problems and NEEDS to be recalled before someone does lose their life. Ford has claimed this to be due to the adaptive learning software in the truck, but coincidentally has also redesigned a critical component in the transmission that causes these types issues three times now, but with zero effort to notify the customer of the risk or to openly address the problem.
Jul 03, 2025
I started hearing a ticking sound under the dash on the driver's side. Then it would blow hot air on drivers side and cold air on passenger side whether it was on heat or air conditioning. We also smelt plastic once in awhile. I took it in and was told it was it was the actuator. They replaced that and that took care of the noise but not the 2 different air Temps. Took it back and now was told the distribution housing needs to be replaced. I have read on a recall for the HVAC system it could catch on fire so the melting plastic smell concerns me.
May 06, 2025
When I use my back up camera it either goes all black or is distorted to the point where I cannot see what is behind my truck. This occurs randomly when I put the truck in reverse.
Apr 21, 2025
+ 8 more complaints for this component
SERVICE BRAKES
11 complaints
Vehicle is a 2019 Ford Ranger mileage is 25700..just had to have all four rotors and brake pads replaced. rear axle rotors showed unaccepatable pitting causing premature wear on pads, while front showed evidence of intermittent pulsing, causing uneven wear . dealership informed me that their hands were tied, this was considfered a normal wear and tear. Ford Customer Care also informed me that there were no programs at this moment to address this problem. I have noticed on your site that there are consumer complaints about the brakes on this vehicle and it's my request that further investigation of the brakes and materials is warranted
May 25, 2023
This trucks rear brake pads have been wearing unevenly since it was new. The inside rear brake pads are showing heavy wear and the outside pads are not showing even wear. This truck has been into the Kendall Ford of Wasilla Alaska for service in early 2022 and this was first noted and repaired. Now this issues has been found again by owner/operator. There seems to be and issue with the slid pins/bolts for caliper are not allowing the outside pads to slide when pedal is active. This is not an isolated issue according to blogs I have found on this issue.
Feb 03, 2023
The contact owns a 2019 Ford Ranger. The contact stated while driving 50 MPH and approaching traffic, while depressing the brake pedal the vehicle failed to slow as needed. The contact stated no warning light was illuminated. The contact stated that the Forward Collision Avoidance Emergency Automatic braking activated and stopped the vehicle. The contact took the vehicle to a local dealer however, the mechanic was unable to duplicate the failure. The contact stated that he had experienced the failure a second time. The contact took the vehicle back to the local dealer who was unable to duplicate the failure. The manufacturer had not been informed of the failure. The failure mileage was approximately 11,000.
Sep 16, 2022
The contact owns a 2019 Ford Ranger. The contact stated that while driving at various speeds, the brakes had malfunctioned and the brake pedal was spongy or in some cases would extend to the floor causing the braking distance to be extended. The vehicle was taken to the local dealer who was unable to duplicate the failure and no service was performed. The manufacturer was also notified of the failure. The failure mileage was 19,500.
Oct 12, 2021
When applying brake you have to pump brakes, if going at a low speed you’ll only slow down about 20% if going 50mph or higher you have to pump brakes 2-3 times to get the mushyness to go away and start braking properly
Sep 30, 2021
+ 6 more complaints for this component
SUSPENSION
10 complaints
During a PA State inspection, a leaf spring was discovered to be broken.
Dec 19, 2025
On November 7th. 2025, I took my Ranger to my mechanic for it's yearly emissions and inspection, to have the tires rotated and brakes changed. He called me later that day and had sent me pictures of BOTH rear leaf springs broken off from the under carriage. He stated that he could not tell how long they were like this and asked if I had any issues driving. I did not notice any noise or driving issues. He stated that he is shocked that I did not wreak the truck by loosing control because it should have caused my rear to be bouncing all over. He contacted FORD and asked if there was a recall on them and was told "No". He then instructed me to file a complaint with you. He ordered the parts and replaced fixed the issue.
Dec 05, 2025
The front eyes of both leaf springs were broke. Took truck to local shop to repair a tire leak and they called me to ask me how I drove the truck there as they never saw anything like it before. This is a major component that maintains the rear axle geometry and could have been a safety risk and should never be a concern on a 5 year old vehicle with under 100,000 miles. Vehicle has not been inspected by any other parties than the shop and myself. No symptoms were detected.
Nov 17, 2025
Both rear leaf springs broke at the eye on the forward anchor bushing, leaving both leaf springs not anchored at one end. This was undetectable until the truck was lifted for an oil change. It was not detected and released back to me to drive. The rear axle was only anchored at 2 of the 3 anchor points. If one of the other anchor points was compromised the result could have been catastrophic depending on the driving conditions. I drove the vehicle locally until i figured out the clunking noise. Both leaf springs were replaced by a certified repair shop. There have been other reports of the same problem with no re-calls
Nov 07, 2025
Driver side leaf spring broke
Jun 17, 2025
+ 5 more complaints for this component
EXTERIOR LIGHTING
10 complaints
My complaint isn't about my vehicle. My complaint pertains to pickup truck and SUV lighting. The lighting on these vehicles have become so bright that they blind oncoming drivers. In addition, I was recently blinded by the lights on a lifted pickup truck, that was following behind me. The lights on these vehicles have become so bright that they present a hazard to other drivers. This hazard is made worse when the vehicles are lifted (body or big wheels). Please consider taking action to address this problem.
Nov 24, 2025
I took this vehicle in on 5-19-2020 for recall (19543/NSTSA Recall 19V-839). Local dealership removed skid plate, inspection/pass. Over the next 3 yrs. the p/u was taken in because of battery drainage & then battery replacement. May 2024 it was taken in as all the rear lights stopped working (exactly what was stated in the recall letter would happen). Was told at the time that the topper, which a very reputable dealer put on, did the wiring wrong so I was charged over $1300 for repairing the wiring. The topper was put on in 2019, recall was 2020, and nothing was found then. An inspection was done and not replacement of rear lights wiring. I came very close to several rear-end collisions as I hadn't realized no rear lights in May 2024. Now, I'm getting "System Off to save battery. Please turn ignition off or start engine" again on the console. I've contacted Ford at Dearborn and was referred back to local dealership and they have given me the run around. I was in a week and half ago to show them all the paperwork, was told they'd look it over and give me a call. I've heard nothing. I'm upset that the recall work wasn't done in 2020 but had to pay for the same work to be done in 2024. Since the work done in May 2024 really didn't handle the battery being drained, I'd like a new pickup as this one seems to be a lemon, or the dealership isn't doing what they said they did. I have paperwork, but it wouldn't scan onto document.
Oct 25, 2024
I HAVE TWO FORD TRUCKS AND BOTH HAVE INSTRUMENT PANELS THAT ARE IMPOSSIBLE TO READ IN DAYLIGHT EXCEPT FOR THE SPEEDOMETERS. THEY BOTH HAVE THE DASH LIGHTS TURNED UP AS BRIGHT AS THEY WILL GO. NOT BEING ABLE TO READ MY INSTRUMENT PANEL GAUGES IS A DANGER FOR MULTIPLE REASONS.
Mar 03, 2021
SAFETY RECALL 19V-839 HAVE LETTER STATING PARTS ARE AVAILABLE TOOK VEHICLE IN TO DEALER 07/23/2020 NO PARTS AVAILABLE, IT IS 08/04/2020 STILL NO PARTS AVAILABLE AND DEALER CAN NOT TELL ME WHEN PARTS WILL BE AVAILABLE.
Aug 04, 2020
TL* THE CONTACT OWNS A 2019 FORD RANGER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V839000 (EXTERIOR LIGHTING) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. AN UNKNOWN DEALER WAS CONTACTED AND CONFIRMED THAT THE PART WAS NOT YET AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
Jul 10, 2020
+ 5 more complaints for this component
ENGINE
10 complaints
The contact owns a 2019 Ford Ranger. The contact stated while driving approximately 60 MPH and hauling a trailer, the vehicle unintendedly decelerated and stalled. The vehicle was towed to the local dealer who diagnosed the vehicle and determined that there was rainwater inside the engine cylinders, causing two spark plugs to rust and malfunction. The spark plugs, spark plug boots, and spark plug coils were replaced and the vehicle was repaired. The contact stated that recently, while the vehicle was in for routine maintenance, the mechanic discovered rainwater inside the engine cylinders again. The vehicle was not yet repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The contact was informed that the VIN was not included in an Extended Warranty coverage related to the failure. The failure mileage was 44,825.
Jul 24, 2025
Truck has issue with crank position sensor issue caused due to defective design of on 2.3l ecoboost first incident shut off at 65 mph took the dealer was told it was defective crank position sensor second time a month later same thing happens third time three or four months later happens again take the dealer this time they said that it was oil permeation on the sensor itself said it was due to leak in front timing cover of motor whereas oil had ripped onto the sensor causing it to not be triggered therefore shutting down the truck completely no limp mode just dead no power also lost all systems including adaptive cruise control, anti-lock brakes, traction control, power steering, forward radar everything!! luckily all three times that this has happened have managed to not crash or get hit in the process of malfunction.my complaint is that this is a four-wheel drive truck and if the sensor is that touchy then maybe they should have shielded it now dealers requesting $2,200 to fix problem after already paying $1500 the first time to have it fixed
Jul 03, 2025
At 68k miles and one month past the 5 year warranty, the CDF drum broke off causing metal to fly loose in the transmission/ creating etchings in the transmission. The entire transmission needed to be replaced because of loss of pressure in the transmission. The vehicle was attempting to shift into first and second gear driving at 80mph.
Feb 05, 2025
Has same cracked valve issue showing up in f150
Oct 07, 2023
2019 Ford Ranger Problem-1- Engine tried to stall several times during driving and operation. Problem-2- When trying to shift from Park to forward or Reverse, the engine shuts off. My truck has been at the dealership for several weeks now and they have not been able to fix or identify the cause.
Oct 04, 2023
+ 5 more complaints for this component
VISIBILITY
10 complaints
The contact owns a 2019 Ford Ranger. The contact stated that while driving at an undisclosed speed, the HVAC blower motor failed to blow cold or hot air as needed. The failure caused the defroster to be inoperable and failed to defrost the front windshield. The vehicle was taken to the dealer, where it was diagnosed that the climate control housing box needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and confirmed that there was no recall associated with the VIN. The failure mileage was approximately 26,662.
Jun 29, 2023
The contact owns a 2019 Ford Ranger. The contact stated that upon activating the air condition, the vents failed to blow cold or redirect airflow. The contact stated that due to the failure as a result, the defogger and defroster failed to operate as needed. There were warning lights illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the front pre-tensioner and air intake damper position sensor. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 19V726000 (Visibility). The vehicle was not repaired. The manufacturer was notified, and a case was opened. The failure mileage was 31,500.
Jun 09, 2023
The contact owns a 2019 Ford Ranger. The contact stated while driving 45 MPH, hot air was entering through the vents. The contact stated no warning light was illuminated. The contact took the vehicle to the local dealer, where it was diagnosed with needing the air distribution box to be replaced. The vehicle was not repaired. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 20V137000 (Visibility) however, the VIN was not included. The manufacturer had been informed of the failure. The failure mileage was approximately 42,000.
Apr 13, 2023
The contact owns a 2019 Ford Ranger. The contact stated that while driving at an undisclosed speed, he heard a clicking and popping sound when attempting to operate the air conditioning unit. The vehicle was taken to an independent mechanic where it was diagnosed that the blend door actuator and air conditioning flow box failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but, no assistance was provided. The failure mileage was 27,682.
Feb 15, 2023
Very simple I believe this car fall into the recall discovered under Motor Company is issuing a safety recall for select 2019 Ford Ranger vehicles. Affected vehicles had the heating, ventilation and air conditioning, or HVAC, blower motor replaced from Oct. 9 to Nov. 22, 2019, per recall 19534. My car has only 27k miles and ac it’s blowing hot !!! Dealer would not repair it because vin did not “have” a recall but it’s the same exact issue above
Feb 03, 2023
+ 5 more complaints for this component
SEATS
6 complaints
I HAD NOTED SEVERAL MONTHS AGO THAT THE BACK OS THE BACK SEAT WOULD NOT LATCH LEAVING IT TO SWING FORWARD WHEN COMING TO A STOP AND SLAMMING BACK WHEN ACCELERATING. WHEN I CHECKED THE LATCH I COULD NOT REMEDY THE PROBLEM. I BROUGHT MY TRUCK INTO CAPITAL FORD IN CARSON CITY FOR SOME OTHER PROBLEM AND ASKED THEM TO TAKE A LOOK AT THE SEAT PROBLEM. AFTER OTHER REPAIRS WERE DONE, MY SERVICE ADVISOR, JOSEPH CONROY ADVISED ME THAT THE REPAIR OF THE SEAT WOULD COST APPROX. $400-$500. CONROY ALSO RELATED THAT THE LATCH PART WOULD NEED TO BE REPLACED. I ASKED WHAT COULD HAVE CAUSED THE PART TO FAIL AND HE REPLIED BY SAYING THAT THE PART HAD GONE THROUGH A RE-DESIGN AND A SERVICE BULLETIN FOR THE REPAIR WAS SENT OUT TO DEALERSHIPS. WHEN I SAID THAT THIS APPEARED TO BE A SAFETY RECALL ISSUE AND THAT I HAD NOT RECEIVED ANY NOTICE OF THE PART REDESIGN, HE TOLD ME TO CONTACT FORD. I CONTACTED FORD AND WAS ASSIGNED TO "LAPORTIA" AS MY ADVISOR AND SHE IS WORKING TOWARDS SECURING FINANCIAL ASSISTANCE TO PAY FOR THE REPAIR, BUT NO INTEREST IN THE SAFETY ASPECT OF THE COMPLAINT. MY TRUCK'S ORIGINAL WARRANTY ENDED JUST THIS PAST DECEMBER BUT IS STILL COVERED BY AN EXTENDED WARRANTY.
Jun 04, 2025
The drivers side seat heater short circuited and melted the seat cover and foam. The short circuit left an approximately 1 inch hole through the seat.
Nov 18, 2022
The contact owns a 2019 Ford Ranger. The contact stated that the heated seat overheated to the point where the contact received severe burns along the back down to the back of the legs. The contact had not taken the vehicle to the dealer to be diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 40,000.
Nov 09, 2022
As I was driving down the road I began I started to smell something unusual - in a way it smelled like burning plastic and/or anti-freeze. I then began to feel quite a bit more heat than usual on my lower back, so much I knew something was wrong. I pulled my truck over, got out and as soon as I got out my heated seat started producing smoke where I believe the main heated seat coil is. Within seconds a flame burst out from the seat. I luckily had a drink in my cup holder that I reached over to grab & pour out on the flame. It kept smoking after I dumped the liquid on it. I then grabbed a water bottle from my back seat & was able to put the fire out completely. In conclusion, my 2019 Ford Ranger Lariat Crew Cab heated seat caught fire while it was turned on, on 9/15/2022 at approx. 9:00a.
Sep 15, 2022
REAR SEAT LATCH IS DEFECTIVE, DOES NOT LOCK IN PLACE AND IF IN A CRASH WILL INJURE OCCUPANTS IN BACKSEAT. BACKSEAT CAME FORWARD WHEN I HIT BRAKES TO AVOID COLLISION. LUCKILY NO ONE WAS IN BACKSEAT.
Apr 12, 2021
+ 1 more complaint for this component
VEHICLE SPEED CONTROL
6 complaints
The contact owns a 2019 Ford Ranger. The contact stated while driving 10 MPH in the driveway and depressing the brake pedal to make a turn, the vehicle lunged forward and accelerated unintendedly. The contact stated that upon depressing the brake pedal, the vehicle failed to respond. The contact continuously depressed the brake pedal until the vehicle responded as needed. There was no warning light illuminated. The dealer was notified of the failure and informed the contact that the VIN was not included in a related recall. The contact stated while her husband was in the process of parking the vehicle in the driveway, the contact's husband depressed the accelerator pedal to drive forward, and the failure recurred, causing the vehicle to crash into two other unoccupied vehicles that were parked in the driveway. The air bags did not deploy. There was no injury sustained. No police report was filed. There was no property damage. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 11,055.
Mar 13, 2025
The contact owns a 2019 Ford Ranger. The contact stated while driving 70 MPH with the cruise control activated, the vehicle made an abnormal sound. The contact stated that he decelerated to 30 MPH, and then re-activated the cruise control. While at a stop sign, the vehicle lost motive power. The vehicle was not diagnosed nor repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 40,000.
Feb 21, 2023
The contact owns a 2019 Ford Ranger. The contact stated that while driving at various speeds, there was difficulty removing his foot off the accelerator pedal to depress the brake pedal due to the plastic and hump around the pedals. The contact mentioned that the vehicle was because he may crash if the brake pedal could not be depressed. The vehicle was taken to the dealer where they informed the contact that there was nothing they could do. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 6,000. THE CONSUMER STATED AFTER REMOVING THE GROUND CABLE, ALL INFO ERASED ON THE COMPUTER.
Nov 03, 2021
ON WEDNESDAY OCT. 14, 2020 ON A TRIP FROM GAINESVILLE, GA TO PENSACOLA, FL I EXPERIENCED A PROBLEM WITH THIS VEHICLE THAT I WOULD CLASSIFY AS POTENTIALLY CATASTROPHIC. WHILE DRIVING ON THE INTERSTATE (I-85), I USED THE CRUISE CONTROL SEVERAL TIMES AT SPEEDS BETWEEN 60 -70 MPH. IN MONTGOMERY, AL, I EXITED OFF THE INTERSTATE AND STOPPED AT A STOP LIGHT. ALL OF A SUDDEN THE ACCELERATION INCREASED WHERE I HAD TO PUT MAXIMUM PRESSURE ON THE BRAKES TO PREVENT THE TRUCK FROM CRASHING INTO PASSING TRAFFIC. I THEN MOVED THE SELECT SHIFT FROM DRIVE TO NEUTRAL AND THEN TO PARK, WHICH STOPPED THE ACCELERATION. THE ACCELERATION WAS SO SEVERE THAT THE REAR WHEELS WERE SPINNING. AGAIN WE EXPERIENCED THE SAME PROBLEM TWICE MORE ON OUR WAY TO PENSACOLA AT VARIOUS STOP LIGHTS. THAT DAY I HAD NOT YET DETERMINED THAT THERE MAY BE AN ISSUE WITH THE OPERATION OF CRUISE CONTROL. THE NEXT MORNING THURSDAY, OCT. 15, I BROUGHT THE TRUCK INTO WORLD FORD IN PENSACOLA, FL. FOR A DIAGNOSIS. THE SERVICE TECHNICIAN TOOK THE TRUCK OUT ON THE HIGHWAY BUT WAS NOT ABLE TO DUPLICATE THE PROBLEM. WHEN HE USED THE DIAGNOSIS MACHINE HE DETECTED A GLITCH IN TEST A4 WHICH INDICATED AN INTERMITTENT INOPERATIVE BRAKE LAMP SWITCH. HE WAS NOT 100% SURE THE BRAKE LAMP SWITCH WAS THE CAUSE OF THE PROBLEM BUT HE CHANGED THE SWITCH. HE WAS VERY CONCERNED OF THE POTENTIAL SERIOUSNESS OF THE SITUATION. WE NEVER HAD ANOTHER ISSUE WHILE IN PENSACOLA OR ON THE WAY HOME, BUT I NEVER TURNED THE CRUISE CONTROL ON, AS MY CONFIDENCE LEVEL WAS STILL VERY LOW.
Dec 09, 2020
WHEN TRYING TO SET THE CRUISE CONTROL SPEED THE VEHICLE WILL CONTINUE ACCELERATING CONSTANTLY. THE TRUCK WILL NOT SET AT THE DESIRED SPEED AND WILL KEEP GOING FASTER AND FASTER. THE ONLY WAY STOP THE INCREASING ACCELERATION PROCESS IS STEPPING ON THE BRAKE, MAYBE TURNING THE CRUISE CONTROL OFF. THIS HAPPENED EVERY TIME I TRIED TO SET THE CRUISE CONTROL SPEED WITH THE BOTTOM ON THE RIGHT SIDE OF THE WHEEL. I REPLICATED THE ISSUE TWICE IN THE PARKWAY JUST TO MAKE SURE THIS WAS NOT MY FAULT. THE FIRST TIME THIS HAPPENED WAS TOTALLY UNEXPECTED, THE CAR WAS NEW.
Jul 06, 2020
+ 1 more complaint for this component
BACK OVER PREVENTION
5 complaints
The contact owns a 2019 Ford Ranger. The contact stated that while in reverse(R), the backup camera initially projected three lines at the bottom of the screen, distorting the driver’s vision. The contact stated that over time, the camera displayed a blank or distorted image, and the message "Camera Not Accessible" was displayed. The vehicle was taken to a dealer, and the backup camera was reset. The reset initially repaired the failure; however, the failure returned soon after the reset. The contact made two attempts to reach the manufacturer, but the call was disconnected each time. The vehicle was not repaired. The failure mileage was approximately 56,000.
Nov 03, 2025
The contact owns a 2019 Ford Ranger. The contact received notification of NHTSA Campaign Number: 25V442000 (BACK OVER PREVENTION); however, the dealer refused to perform the recall repair. The contact stated that the rearview camera displayed a black screen while the vehicle was in reverse(R). The contact stated that the failure had obstructed the driver's visibility, which prevented the driver from safely operating the vehicle. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 33,000.
Sep 17, 2025
The contact owns a 2019 Ford Ranger. The contact stated that the rearview camera displayed a black screen while the vehicle was in reverse(R). The contact stated that the failure obstructed the visibility, and the contact was prevented from safely operating the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer; however, the vehicle was not diagnosed or inspected. The vehicle was not repaired because the VIN was not under recall. The contact stated that the failure persisted. The contact related the failure to NHTSA Campaign Number: 25V442000 (BACK OVER PREVENTION). The manufacturer was not notified of the failure. The failure mileage was approximately 19,000.
Jul 03, 2025
Back up camera is blurry unable to identify objects. I know there’s been a recall on many of the back up cameras but none on my vehicle since I have a back up camera that is blurry and unable to identify objects. Clearly, how do I go about getting it fixed?
Jan 17, 2023
My rear camera stopped working and I think the front collision alert is affected as well. I understand there was/is a recall for this issue but not my vehicle. I do not understand why.
Jul 11, 2022
WHEELS
4 complaints
The contact owns a 2019 Ford Ranger. The contact stated that while the vehicle was at the dealer for a tire rotation, the contact was informed that the tires were unable to be rebalanced due to swollen lug nuts. The vehicle was then taken to Goodyear, who was also unable to rotate the tires. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 106,000.
Jul 16, 2025
The spare tire is held tight against the under body of the pickup bed with a chain crank. The gear mechanism that raises and lowers the tire slowly released the tire to the point that edge of the tire (presumably due to bumps in the road) contacted the pavement. The tire became almost vertical and at a right angle to the direction of the vehicle. An estimated 4 miles was drive before the driver became aware of the problem when an observant motorcyclist motioned the vehicle over. The tire was very hot where it contacted the pavement but had not yet ignited. The tire was roped to the frame to keep it off the pavement to safely drive to a service center. The photo of the tire under the truck shows its approximate position during the incident. The actual position was almost vertical. The photo of the tire chain clamp bracket shows it's position without the tire. The crank mechanism was damaged to the point that the chain could not raise or lower the bracket. A tire fire would have resulted if the vehicle was driven much further. The manufacturer will be contacted.
Jul 13, 2021
2019 FORD RANGER PURCHASED NOV. 2019 HAS 18,00 MILES. TIRES WEARING OUT ON INSIDE FRONT TIRES. BROUGHT TO DEALER FOR ALIGNMENT, BUT THEY WERE BUSY, TOOK IT TO NEARBY SHOP AND THEY ALIGNED IT, BUT SAID IT WAS NOT THAT OUT OF ALIGNMENT. THEY CHECKED THE TIRES AND STATED THAT ALL 4 TIRES WERE SEPARATED.
Aug 11, 2020
HAD 2 REAR TIRES FAIL WITHIN THE FIRST 5000 MILES. THE FIRST AT 3900 MILES DEVELOPED A BLISTER ON THE SIDEWALL AND WENT FLAT. THE SECOND AT ABOUT 300 MILES LATER DEVELOPED A SLOW LEAK THAT COULD NOT BE FIXED
Oct 11, 2019
SEAT BELTS
4 complaints
The seat belt does not engage.
Jun 17, 2024
My seat belt buckle stopped working (part number KB3Z-2161203-AB) and despite the fact that my truck is less than 5 years old and has less than 60K miles on it Ford's service system says this part is not covered under the 5 year 60K mile Safety Restraint System nor the Premium Care extended warranties I have on the truck. Documentation for the warranties suggests it does but the system the Ford service techs use says no. When I've escalated to Customer Care, they claim "there is nothing they can do." Ford Protect (warranty department) says the same thing. A helpful Ford tech on the internet claims he looked into it and says the problem is that the Ford service system has the part misclassified as a "trim" part and not a "safety" part so it only recognizes it as something covered by the 3 year 36K mile bumper to bumper warranty. When I pressed and they sent me to Ford Financial Assistance for a "Goodwill Repair" I was told they would only cover 40%. I have presented pictures to Ford of their own warranty documentation that clearly states the seat belt buckles are covered and they repeatedly have pushed back saying "there is nothing we can do, it's denied." Bringing it to your attention in the hopes you can help me find the right folks at Ford to remedy this issue as anyone who has a Ford with this same base part number (2161203) is going to have this problem. I'm attaching a copy of the Ford Warranty Safety Section and a copy of the online listing for the Seat Belt Buckle.
Jan 10, 2024
Front Passenger seatbelt locks up every single time it is used. It has been an issue since day one of purchasing the vehicle. (There is a recall for this issue, however my specific VIN is not listed.) This is a major concern of safety.
Sep 19, 2023
Possible Drivers side seat belt problem on 2019 Ford Ranger. Incident occurred on Monday 12/20/202, ABOUT 9:20 AM. After rounding a corner at low speed I hit a patch of ice and, spinning about 90 degrees, ran head on into a very tall power pole, anchored to its concrete base with many very large bolts. This stopped me. No damage to the post. Air bags did not deploy, but I was thrust forward, hitting the steering wheel hard. I bruised my chest, not visibly, in the sternum area. I think my seat belt must have failed. The force on the belt ripped the plastic paneling covering it from the sidewalls. My truck is now in the body shop being evaluated. I pointed out the seat belt problem and they said they can give me a new one if there is a problem.
Dec 21, 2021
ELECTRICAL SYSTEM,UNKNOWN OR OTHER
4 complaints
HVAC BLOWER MOTOR NEEDS REPLACED AND EVAP BOX PER FORD DEALERSHIP TODD JUDY FORD. THERE HAS BEEN A PREVIOUS RECALL ON THE SAME MODEL FORD RANGER YEAR 2019. AIR CONDITIONING WORK FINE ON THE PASSENGER VENTS BUT BLOWS OUT HOT AIR ON DRIVERS SIDE. 2 SEPARATE MECHANICS AT INDEPENDENT MECHANIC AND TODD JUDY FORD DEALERSHIP REPORT THERE HAVE BEEN PROBLEMS WITH THE FORD RANGER AIR CONDITIONING AND HEATING SYSTEM REGARDING DUAL TEMPERATURE UNITS. DEALERSHIP REPORTS THAT THIS IS NOT COVERED UNDER WARRANTY AND IS ESTIMATED $3200 IN REPAIR. THE INDEPENDENT MECHANIC IS NOT ABLE TO OBTAIN THE PART AND DISCOVERED THERE WAS A PREVIOUS RECALL ON THIS PART ON THE 2019 FORD RANGER. I HAVE CONTACTED FORD CUSTOMER SERVICE DEPARTMENT AND THEY SPECIFY THAT THIS PART AND FAILURE OF MY 2019 FORD RANGER DOES NOT HAVE MY VEHICLE LISTED UNDER THE RECALL ALTHOUGH IT IS THE SAME MODEL. THE PROBLEM WAS DISCOVERED ON [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
May 20, 2024
See related steering problem report. After Electronic Power Steering Assist went out on vehicle without warning of any kind to owner, dealer's service department diagnostics as best as I can determine did NOT indicate a problem with the parts that were replaced. The parts replaced were: 1. steering gear/rack and pinion/EPAS (which seems to go by various names), and, when installing this new, expensive, and long-in-coming part didn't get the power steering to work, 2. the battery. The scenario suggests that the root problem was the battery, not the steering gear. A representative of another dealer has advised that the first thing they check in cases involving electronic components is the battery. He also advised that Ford does not have a standard operating procedure or service bulletin that says this is something that is to be done. Can this be? Apparently, at least for this vehicle, there was/is no system to check for adequate battery voltage or to warn that electronic components like the power steering may fail if the battery is not replaced. If my research results are correct, the Diagnostic Trouble Codes the Ford dealer repair tech found went to a steering angle sensor in the steering column, and things having to do with the anti-lock brake system. They weren't fixed, but the codes disappeared after the new battery was installed. The diagnostic tools seem to give more misdirection than direction. With so many critical electrical components in today's vehicles, the warning and diagnostic systems seem woefully inadequate. I have read about Fords limiting battery recharging to about 75% and have noted that one of the DTCs involved here, U3003, sets on-demand if the voltage supplies to the ABS module falls below 10 volts. I'm a layman, but these things suggest to me that some of the electronic components require substantial minimum operating voltage which an older battery would not supply, and the recharging cap could exacerbate the problem.
Jul 18, 2023
On Jan 04,2022 while flat towing my truck behind my motorhome it caught fire and burned to the ground. It was too badly burned for the insurance to make a determination of the cause. However, it started in the engine compartment. I know it was not a bad tire because all tires were inflated until the fire popped them. I was able to get the truck disconnected from the RV and know that it remain in Neutral with nothing seized up like the transmission or brakes because the truck rolled on its own once it was disconnected and had to be chocked. I had followed all the proper procedures and my key was in acc position. I had towed this truck many hundred miles prior. That day I had towed it 5-6 hours prior to the fire. This incident took place in Alachua County Florida. Alachua County Fire Rescur case # ACFR22-0000462 Alachua Police Department case #22APD00014 State Farm Insurance Claim #36-29co-58s
Feb 07, 2022
TAIL LIGHT RECALL: TOOK VEHICLE TO GRAPEVINE FORD IN GRAPEVINE TX AND THEY SAID THEY HAD DONE THE WORK. LOOKING AT THE DATABASE IT STILL SHOWS NO REPAIRED. UNSURE WHAT TO DO ABOUT IT.
Dec 18, 2019
VISIBILITY/WIPER
4 complaints
Known issue with 2019 Ford Rangers where they've issued a safety recall on SOME, but not ALL Rangers in that year. Related to SSM [XXX]: 2019-2020 Ranger - Climate Control Temperature Will Not Adjust With Clicking/Snapping Noise From The Dash - Built On Or Before 30-Jul-2020. Related to recall 19S34. There is an online thread with over 20 pages on [XXX] [XXX] ) where numerous people have reported this issue where one side no longer has A/C. This is dangerous as A/C is required in the winter to help dehumidify the air before it goes across the heater core to defrost the windshield. Ford does not want to issue a recall for all models because it's a labor intensive costly repair to replace the HVAC Distribution Box. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Feb 14, 2024
It looks like on some 2019 Ford Rangers (mine included), there is a faulty blend door in the heater box assembly. Note this issue is not present in other model years due to Ford correcting the defective part. This defective part causes the switch between hot and cold air to fail. My truck got stuck on hot and the dealer replaced it under warranty. The replacement has now failed 6 months (3000) miles later. This issue can prevent the heat from functioning properly in cold weather, which means the defrost is ineffective - requiring the driver to manually clear the windshield. The issue is that Ford A) knows there is a defect that can impact the safe operation of the vehicle B) These vehicles would likely be covered under the manufacturer warranty due to low miles from 2020 (COVID) but has not made efforts to notify owners of the defect C) will gladly charge $3,000-$4,000 for this repair once the warranty expires (which has happened for many 2019 vehicles by this point). Profiteering on a known factory defect is unacceptable!
Jan 20, 2023
THOUSANDS OF TINY SPECS IN WINDSHIELD OBSCURE VISIBILITY IN CERTAIN LIGHT - MORNING, LATE AFTERNOON. HAPPENS SUDDENLY AND COULD CAUSE INABILITY TO SEE INCOMING CAR OR PEDESTRIAN, BICYCLES!! VERY FRIGHTENING. RESEARCH ONLINE REVEALS MANY HAVE THIS PROBLEM WITH WINDSHIELDS. THIS IS A BRAND NEW TRUCK. I BELIEVE IT IS A DEFECT IN THE WINDSHIELD ON THIS VEHICLE AND OTHERS. COULD CAUSE LOSS OF LIFE AS VISIBILITY IS GREATLY REDUCED AND IT HAPPENS SUDDENLY IN THE LIGHT CONDITIONS DESCRIBED ABOVE DURING ROUTINE DRIVING. THESE SPECKS CAN ALSO BE SEEN WHEN VEHICLE IS STATIONARY IN THE CONDITIONS NOTED. IT IS ESPECIALLY FRIGHTENING IF IT HAPPENS IN AN INTERSECTION, WHILE TURNING, ETC.
Feb 12, 2020
DRIVER'S SIDE WINDOW HAS A FUN-HOUSE DISTORTION IN THE GLASS. THIS MAKES LOOKING OUT THE WINDOW, INCLUDING LOOKING IN THE SIDE-VIEW MIRROR, DIFFICULT AND AFFECTS THE USER'S ATTENTION AND INCITES NAUSEA AND DIZZINESS. THIS IS A 2ND REPLACEMENT, AS THE FIRST WINDOW WAS DEFECTIVE AS WELL. REPLACEMENT IS PENDING, AS FORD IS DRAGGING THEIR FEET ON THE 2ND DEFECTIVE GLASS.
Jan 15, 2020
ENGINE AND ENGINE COOLING
3 complaints
The contact owns a 2019 Ford Ranger. The contact stated that while driving approximately 50 MPH and depressing the accelerator pedal, the check engine warning light started flashing off and on, and the vehicle failed to properly accelerate. The vehicle was later towed to the local dealer, who diagnosed that there was water inside the cylinders, causing a misfire. The contact was advised that the spark plugs, and coil packs needed to be replaced. The vehicle was not yet repaired. The contact was advised to have an engine cover installed to prevent the water intrusion from reoccurring. The contact stated that the higher trim level of the same vehicle came equipped with the engine cover already installed to prevent the failure from occurring. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 28,000. The VIN was not available.
Apr 30, 2025
The contact owns a 2019 Ford Ranger. The contact stated while driving 70 MPH, there was smoke was coming from the rear of the vehicle. There were several unknown warning lights illuminated. The vehicle was taken to the dealer and was diagnosed with coolant intrusion into the cylinder, causing engine failure. The contact was informed that the engine needed to be replaced. The repair was pending. The manufacturer was notified of the failure. The approximate failure mileage was 28,000.
Apr 08, 2025
The contact owns a 2019 Ford Ranger. The contact stated that while driving at approximately 65 MPH, the vehicle started losing motive power. The check engine warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed with an ERG failure. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The contact related the failure to the Customer Satisfaction Program: 21M03. The failure mileage was approximately 185,000.
May 08, 2024
UNKNOWN OR OTHER,VISIBILITY
3 complaints
Heater box went out due to a defective heater door. This caused the front windshield to ice over and not being able to see other traffic. No warm air would come out of the vents .Heater box was replaced by the Dealer at the cost to owner.
Feb 26, 2024
I was driving over a bridge at 65 mph on a foggy morning a couple weeks ago and my windshield fogged over. I turned on the defroster and it only blew cold air. I could not see and I couldn't clear it. I had to slow down and find a safe spot to pull over. I had to try to wipe down the windshield and then start driving. It did it again and i had to pull over again and wipe and wait for it to clear to be able to drive. It was foggy the next morning and I had to do the same thing all over again. I stopped by a ford dealer and spoke to someone. He told me, oh yeah we know all about it and so does ford. The ac heater chamber in the dash breaks. Costs about 2 grand to fix. All the new rangers do it. This is a safety defect and needs to be recalled by ford. Thank you.
Oct 31, 2023
With high outside temperatures A/C unit was on, but only the heating system was working. Air Conditioning system was not functuning and heating system would not go off. With windows down, inside tempearture was over 100 degrees and passing out due to heat was happening. Ford Dealer inspected the problem and said it was a manufacture malfunction. After repairing, the same issue developed again five days later. Ford dealer said it was another malfunctioning manufacture part.
Apr 17, 2023
STEERING
3 complaints
The steering wheel is loose. I tried to get my truck aligned and was told they weren’t able to do it because of the steering wheel being loose
Feb 03, 2024
Owner, who had bought the truck new approx. 3 1/2 years earlier, had driven about three miles on dry, paved, residential, hilly, roads and was returning to where he was staying when he came upon a waiting line of cars. He turned around to go a different way. Coming to a slight curve the power steering (EPAS) went out. Struggling to make the curve, the power assist kicked in and jolted him off the right side of the road. Had the curve been to the left, the truck may have been thrust into the path of an oncoming vehicle. Owner then slowly soldiered on, with the truck making an intermittent noise as if trying to activate the power steering, which it sometimes did, causing the truck to swerve side to side. Owner did not mention any warning sign or alarm or message occurring during this episode. At his destination he called for help and the truck was towed to the dealer. The repair order (RO) indicates diagnostics first being done on 6-8-23, which verified the lack of power steering, and showed DTCs C1B00, U0415, and U3003. My research showed the first pertains to a steering angle sensor in the steering column, and the next two having to do with the ABS. The tech notes indicate he did pinpoint test BC1 (NO), BC2 (YES), and BC3 (YES). Next, the tech reported that the steering gear assembly had a malfunction and needed to be replaced. He added that he retrieved RVC code RA5VUMN131GXQ. Not having the steering gear assembly KB3Z3504A in stock, the replacement was not made until July. The RO said nothing about the battery, but it was learned that it had also been replaced under separate RO, which dealer has yet to provide. The dealer service rep said that even after they charged the old battery, it did not have enough power to activate an essential component; probably the new part, but I can't recall for sure. With the new battery, the DTCs, none of which I believe went to the steering gear, disappeared and the power steering apparently works. Truck is still with dealer.
Jul 18, 2023
The contact owns a 2019 Ford Ranger. The contact stated that upon starting the vehicle, the power steering assist failed with several unknown warning lights illuminated. The contact called the dealer and was informed that the VIN was not under recall. The contact was given an estimate for the repair. The contact called an independent mechanic and was also given an estimate for the repair. Due to the failure, the vehicle was towed to the independent mechanic and the contact was informed that the rack and pinion steering assembly needed to be replaced. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 37,000. The contact stated that the vehicle was repaired.
Feb 13, 2023
ELECTRICAL SYSTEM,VISIBILITY
2 complaints
The contact owns a 2019 Ford Ranger. The contact stated that the temperature failed to adjust as needed. The contact stated that the damper was stuck. The heater was continuously blowing out hot air on the driver's side. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 19V726000 (Visibility). The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and opened a case, and referred the contact to the NHTSA Hotline. The failure mileage was approximately 25,152.
Feb 28, 2025
In May of 2022 at approximatley 46,000 miles a family members 2019 Ford Ranger had the A/C unit on, but VERY hot air was blowing on drivers side. After inspection and Pin Point Test the Ford Dealership determined a manufactures Drivers Side Temp Blend Door was malfunctioning and was replaced at full charge of both parts and labor to the owner. A few days later after the manufactures malfunctioning part was replaced, the VERY same issue developed and caused a family member to pass out due to over 100 degress inside the vehicle. After OTHER inspection by the Ford Dealership it was determined the manufactures Blend Door Acuator, was malfunctioning and was replaced at full charge of both parts and labor to the owner. ON THE WEEK OF APRIL 10, 2023, THIS VIN'S FORD RANGER HAS EXPERIENCED THE EXACT SAME ISSUES AND HAS BEEN DETERMINED THE EXACT SAME MANUFACTURES PARTS ARE MALFUNCTIONING. THIS MUST BE DETERMINED AS A RECALL!
Apr 17, 2023
POWER TRAIN,VEHICLE SPEED CONTROL
2 complaints
The ten-speed transmission "10R80" has Rough and harsh shifting, "upshifts and downshifts," which sometimes causes the vehicle to lunge forward unexpectedly. The dealer has reprogrammed the transmission twice with no change.
Feb 24, 2025
THE TRANSMISSION "BUCKING" DURING SPEED ACCELERATION. THIS CAUSES THE VEHICLE TO DE-ACCELERATE BEFORE ACCELERATING TO DESIRE SPEED. PROBLEM: PROGRAMIMG OF THE PCM FOR THE TRANSMISSION. ACCORDING TO THE DATA COLLECTED ON THE FORD FORUM THIS PROBLEM AFFECTS ALL FORD RANGER FOR 2019 MODELS.
Jan 08, 2024
POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM
2 complaints
There is insufficient shielding to prevent water from reaching the top of the engine. This results in water dripping on the coil packs and also entering the spark plug wells, causing loss of spark and reduced engine output. Over time, this issue also leads to rust in the engine head, potentially resulting in engine failure. Additionally, water can reach the EGR DPFE sensor, causing the engine to hesitate and shutter at various speeds. Both of these issues together cause a misfire when applying the accelerator and will cause the vehicle to initially hesitate then surge forward. Even with the engine cover, the venting at the base of the windshield allows water to drip down on the engine head, causing the above issues. Ford does recognize that there is an issue and have written several TSBs on the it.
Jul 23, 2024
I CHANGED MY OIL AT 5,000 MILES, I HAVE APPROXIMATELY 8,400 MILES ON MY TRUCK NOW. I NOTICED EXCESSIVE FUEL BUILT UP IN MY OIL CATCH CAN. AFTER DOING SOME RESEARCH A LOT OF PEOPLE WITH THE 2019 FORD RANGER ARE HAVING THE SAME ISSUE. I CHECKED MY OIL AND MY OIL WAS SATURATED WITH FUEL. FUEL IS GETTING INTO THE ENGINE OIL.
Feb 02, 2021
AIR BAGS
2 complaints
The contact owned a 2019 Ford Ranger. The contact stated that while driving approximately 50 MPH, the vehicle crashed into a cow. During the incident, the vehicle was destroyed and severe front-end damage had occurred but no airbags deployed. No injuries were reported. A police report was taken at the scene and the vehicle was towed away. The cause of the failure was not determined. The manufacturer was notified of the failure. The local dealer was not contacted. The failure mileage was 54,000. Vehicle has been totaled State Farm with Claim number [XXX]. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).”
Mar 02, 2022
TL* THE CONTACT OWNS A 2007 TOYOTA MATRIX. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V627000 (AIR BAGS). HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER SPITZER TOYOTA MONROEVILLE (4710 WILLIAM PENN HWY, MONROEVILLE, PA 15146) WAS CONTACTED AND CONFIRMED THE PARTS WERE NOT AVAILABLE FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
Feb 19, 2020
FUEL/PROPULSION SYSTEM
2 complaints
CONSISTENT ISSUE WITH FUEL IN OIL. LATEST REPORT FROM THE OIL ANALYSIS HAVE 4.5 PERCENT FUEL IN OIL. DROPPING OIL IGNITION POINT TO 285 DEGREES. ISSUE OCCURS DURING NORMAL VEHICLE USE.
Jan 02, 2021
EXTREME FUEL DILUTION IN THE OIL. LIKELY FROM LEAKING HIGH PRESSURE FUEL PUMP. I HAVE ATTACHED THE RESULTS FROM OIL ANALYSIS AT 1860 MILES. THE TEST ONLY INDICATES THAT FUEL DILUTION IS ABOVE 5%, WHICH ITSELF LEADS TO SEVERE OIL DEGRADATION. WHEN I CHANGED THE OIL, I DRAINED 7.5 QUARTS OUT OF AN ENGINE WITH A 6.2 QUART CAPACITY. THIS WOULD INDICATE A 21% FUEL DILUTION, NOT INCLUDING FUEL THAT HAS EVAPORATED FROM THE CRANKCASE AND RETURNED TO THE COMBUSTION CHAMBER VIA THE PCV SYSTEM. IF I ABIDED BY THE MANUAL'S RECOMMENDED OIL CHANGE INTERVAL, I HAVE LITTLE DOUBT THE ENGINE WOULD EVENTUALLY CATCH FIRE, BASED ON THE RESULTS OF SEVERAL TESTS COMPARING FUEL DILUTION TO AN OIL'S FLASHPOINT. AFTER CHANGING THE OIL, IT SMELLED FINE FOR THE FIRST 20 MILES OR SO. AFTER THAT, THE OIL BEGAN TO FEEL OF GASOLINE AGAIN. AFTER GOING THROUGH FORD'S SERVICE MANUALS, I HAVE ASCERTAINED THAT THE PROBLEM MUST LIE IN THE HIGH PRESSURE FUEL PUMP. IT RUNS OFF THE CAMSHAFT, WHERE LEAKING FUEL COULD THEN MAKE IT INTO THE ENGINE AND MIX WITH OIL. THERE WOULD BE NO WARNING OR INDICATION, BESIDES RISING OIL LEVELS ACCOMPANIED BY THE SMELL OF GASOLINE IN THE OIL. IT DOES NOT MAKE ME HAPPY THAT MY DEALER IS NOT TAKING THIS ISSUE SERIOUSLY, ESPECIALLY BECAUSE A FUEL LEAK OF ANY KIND ALWAYS HAS THE POTENTIAL TO LEAD TO A FIRE OR EXPLOSION IN THE HOT ENGINE BAY. I PAID OVER $40K FOR THIS TRUCK, AND SHOULD NOT HAVE TO CHANGE THE OIL EVERY 500 MILES TO KEEP IT FROM SELF DESTRUCTING. THANK YOU FOR YOUR HELP IN THE RESOLUTION OF THIS ISSUE. I DON'T FEEL SAFE DRIVING MY FAMILY IN THIS VEHICLE, AND FORD HAS REPEATEDLY CHOSEN NOT TO ADDRESS THE ISSUE. I FIRST DETECTED THE ISSUE ON OCTOBER 20TH, BUT I HAVE NO DOUBT THAT IT HAS BEEN GOING ON SINCE THE TRUCK ROLLED OFF THE ASSEMBLY LINE. I PURCHASED THE VEHICLE ON AUGUST 30TH OF THIS YEAR.
Dec 07, 2019
STRUCTURE
2 complaints
CORROSION PROBLEMS ON THE CHASSIS WILL BE CORRECTED BY DELAER. IT IS NOT THE FIRST VEHICLE OF THIS MODEL THAT I SEE WITH THE SAME PROBLEM. I HAVE MORE PHOTOS.
Jul 17, 2020
CHASSIS CORROSION PROBLEMS. DEALER TRADED THE UNIT FOR ANOTHER. NOTE SEVERAL WITH THE SAME CORROSION PROBLEM.
Jul 17, 2020
POWER TRAIN,FORWARD COLLISION AVOIDANCE
1 complaint
The vehicle is experiencing a severe power train failure involving erratic and violent gear selection. The transmission unexpectedly jumps from 2nd, 3rd, or 4th gear directly up to 7th or 8th gear, resulting in a total loss of acceleration. This is immediately followed by the transmission "slamming" down into lower gears, usually 1st or 2nd gear without driver input. This behavior is accompanied by a strong burning smell and a dashboard "wrench" warning light. The symptoms match the manufacturing defect documented in Ford TSB 24-2101 (CDF clutch drum). Diagnosis & Manufacturer Response: The issue began in October 2025 with a noticeable transmission shudder. I paid for two transmission flushes at Big O Tires to attempt to resolve the issue, but the mechanical failure has since escalated. When the "wrench" light appeared, an independent diagnostic computer was unable to retrieve an error code, as the light is a proprietary Ford powertrain indicator. Furthermore, the wrench light clears upon restarting the vehicle, despite the violent shifting and burning smell remaining. Ford Corporate agents claim there are "no known issues" and have refused to assist with towing, despite an active NHTSA Engineering Analysis (PE 24-001) regarding this exact 10R80 transmission. Safety Risk: This defect creates an extreme safety hazard. Violent downshifting into low gears at highway speeds can cause a loss of vehicle control or a rear-end collision. The burning smell indicates internal friction and fluid oxidation, posing an immediate fire risk or the potential for a catastrophic mechanical lock-up.
Jan 27, 2026
ELECTRICAL SYSTEM,UNKNOWN OR OTHER,VISIBILITY/WIPER
1 complaint
The climate control system on my 2019 Ford Ranger has a recurring failure that prevents the vehicle from properly adjusting temperature or directing air through the vents. The failure causes a constant clicking/snapping noise behind the dashboard, and the blend door does not move when the temperature is changed. This malfunction matches Ford’s published SSM 49264, which identifies a known defect in 2019–2020 Rangers built on or before 7/30/2020 and states that the entire HVAC housing assembly must be replaced. This issue creates a safety hazard because the truck cannot reliably defrost the windshield in cold or wet weather. Loss of defrosting capability severely limits visibility and makes safe operation of the vehicle difficult. The issue is reproducible every time the temperature is adjusted. The problem began when the vehicle was still within the original mileage window of the factory warranty, but the dealership did not repair it. Ford has confirmed the malfunction is caused by the blend door system, yet they have refused goodwill coverage for a repair that requires full dash removal and replacement of a known defective part. There were no warning lights, but the clicking noise and loss of temperature control began well before the warranty expired. The vehicle continues to experience the defect, and it poses an ongoing visibility and safety risk. Ford has acknowledged this exact failure mode in writing (SSM 49264), but has not issued a recall or safety campaign.
Dec 11, 2025
POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE
1 complaint
Truck looses gear when pulling into traffic. It will shift out of gear and only allow coasting. At speeds of 40 MPH and higher it will down shift causing dramatic reduced speed with no brake warning to other drivers behind. It will also randomly loose power. It will have delayed shifts squealing tires upon shifting and excessive jerking that is uncontrollable.
Dec 10, 2025
ELECTRICAL SYSTEM,STRUCTURE,ENGINE
1 complaint
Hood/cowling along the windshield allows water to leak under the hood of the vehicle and wets the coils and plugs causing the engine to mis fire and shutter violently. This engine mis fire and sudden lack of power can cause the vehicle to obstruct the flow of traffic resulting in an accident. Problem was reproduced by the dealer and they replace coils, plugs, and installed an accessory engine cover to prevent the issue in the future. All at my cost. The problem remains that there are many Ford Rangers on the road unaware of this problem. This problem is documented in a Ford TSB but a more aggressive approaching is needed to resolve this issue.
Dec 03, 2025
POWER TRAIN,FUEL/PROPULSION SYSTEM
1 complaint
My 2019 Ford Ranger 4x4 was bought new in April of 2019 and has approxiamatly 73,400 miles. Over time a slight glitch in the transission got to be more frequent. When first starting out within the first mile of operation, the vehicle would hang between gears and act like it ran out of fuel for a few seconds at low speed, as in pulling out from a stop sign or accelerating from a dead stop. My guess is inbetween first and second or second and third gear. It just wouldn'd go. Fortunatley I was not involved in any accidents. I can see where this could easily cause a mjor accident. There are several TSB's for this transmission and I believe Ford and General Motors use this same transmission. I have had my truck at the dealer for almost a month after it got scary to drive it got scary to drive. They are repairing this and contributing to the cost. I feel ike they no there is a problem and probably should have done a recall before someone gets killed.
Oct 13, 2025
LANE DEPARTURE,BACK OVER PREVENTION
1 complaint
While backing up out of a parking space, my BLIS system did not give me a warning letting me know there was a pole to my left side...finally, it beeped just once as I backed into the pole...no other warning. Estimate of repair is $4900. My neighbor was with me and can confirm everything
Sep 26, 2025
POWER TRAIN,ELECTRICAL SYSTEM,SEAT BELTS
1 complaint
Air bag malfunctions and not active passanger and driver side, hvac malfunction replaced twice, power train shifting out of gears, PCM malfunctions and triggering failures to sensors. Passanger seat belt not working. Collision sensor malfunction and not working.
Aug 31, 2025
ENGINE AND ENGINE COOLING,POWER TRAIN
1 complaint
The contact owns a 2019 Ford Ranger. The contact stated that while driving 65 MPH, the vehicle decelerated to 35 MPH. The contact stated that while driving at various speeds, the transmission was skipping gear, slipping, and shifting hard. The check engine warning light was briefly illuminated. The vehicle was taken to the dealer, who diagnosed that the head gasket was failing. The dealer stated that coolant was intruding into the engine, and there was engine oil was entering into the spark plugs, causing engine failure. The dealer also diagnosed the vehicle with transmission failure. The head gasket and the transmission were replaced; however, the failure persisted. The dealer informed the contact that the vehicle needed to be drive more often for the vehicle to run properly. The dealer was unable to duplicate the failure. The vehicle was taken to another dealer, Mountain Grove Ford (11311 Bus Dr #60, Mountain Grove, MO 65711); and the vehicle was diagnosed with a transmission fluid leak and fractured head gasket. The head gasket was replaced; however, the failure persisted. The transmission jerked abnormally when the vehicle was shifted into park on an incline. The vehicle was not repaired. The manufacturer was informed of the failure. The manufacturer opened a case regarding the failures and extended the warranty for the transmission. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 65,000.
Jun 24, 2025
ELECTRICAL SYSTEM,EXTERIOR LIGHTING
1 complaint
After hookup of any type of trailer to electrical on vehicle, left turn signal fails to operate on vehicle or trailer, and warning message is displayed on panel. After disconnection of trailer operation of all turn signals in vehicle resume as designed.
Jun 16, 2025
ELECTRICAL SYSTEM,EXTERIOR LIGHTING,BACK OVER PREVENTION
1 complaint
My tail lights just stopped working. I didn't know that they were out until someone behind me told me that they were out. I didn't have any collision, nothing like that. I called the Ford Dealership and they told me to bring it in so that they can see what the problem is. They have been having issues with tail lights just going out.
Jun 14, 2025
ELECTRICAL SYSTEM,BACK OVER PREVENTION
1 complaint
This is in relation to an existing recall on the 2019 Ford Ranger, NHTSA Recall no. 19V-839 This recall was for improperly connected inline electrical connectors from the Ford factory causing issues with rear brake lamps. I have recently had a fault with the same connector, which Ford technicians discovered was not properly connected. This connector failed due to the loose connection, causing all electrical connections in the rear frame (fuel pump, rear view camera, cross traffic warning, parking sensors) to fail. Upon discovering recall 19V-839, I contacted Ford support. I was informed that my truck was built in the same factory as the recalled vehicles, but was completed three days after the impacted period ( JUN 04, 2018 - AUG 16, 2019). Therefor Ford will not consider my issue part of the recall. Ford has advised me to bring this up to the NHTSA to broaden the scope of the recall. I It seems clear to me that this issue was the same as the recall, and likely the original dates were too narrow. I hope you will investigate this issue.
Apr 03, 2025
LANE DEPARTURE,FORWARD COLLISION AVOIDANCE
1 complaint
Once the "Maintenace Required" message is displayed on the "multi-information display" (shortly prior to standard maintenance intervals), it is permanently displayed . Once the message is displayed, "meter control switches" no longer function (until reset by dealer maintenance). Enabling any ADAS feature (if not enabled) is impossible as this requires using the "meter control switches." While stopped (or not), resetting the "message indicating maintenance" procedure in the user manual does not work (page 447 in [XXX] ) as it requires functional "meter control switches": ■Resetting the message indicating maintenance is required After the required maintenance is performed according to the maintenance schedule, please reset the reminder light or message. To reset the reminder light or message, follow the procedure described below: 1 Press or of the meter control switches and select on the multi-information display. 2 Press or of the meter control switches and select “Vehicle Settings”. Then press and hold . 3 Press or of the meter control switches and select “Scheduled Maintenance”. Then press . 4 Select “Yes” and press . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Jan 29, 2025
POWER TRAIN,VEHICLE SPEED CONTROL,FUEL/PROPULSION SYSTEM
1 complaint
When turning on to another road and accelerating, engine will suddenly loose all power. releasing accelerator will regain some power until vehicle speed increases. Throttle control is often erratic and transmission shifting is inconsistent resulting in hard clunks during shift. Pulling into traffic with a sudden loss of power leaves me vulnerable to a collision.
Jan 18, 2025
ENGINE AND ENGINE COOLING,ENGINE
1 complaint
The contact owns a 2019 Ford Ranger. The contact stated that there was a misfire in the engine. The check engine warning light was illuminated. The vehicle was taken to the local dealer where it was diagnosed that there was water build up in the spark plug wells, and there were signs of corrosion on electrical component. The vehicle was not repaired. The manufacturer was contacted and informed the contact about Technical Service Bulletin Number: 23-2011 and referred the contact to the NHTSA Hotline. The failure mileage was approximately 81,000.
Sep 20, 2024
POWER TRAIN,ENGINE
1 complaint
Manufacture defected valve cover allows water to gather and leak into coils causing vehicle to shut down at highway speeds ! This is EXTREMELY dangerous and FORD admitted knowing of the issue and even has an active internal fix but demands payment to fix issue. My service advisor said Ford has known of this issue but would only repair if the customer pays for it. Please take this matter under heavy consideration as I nearly lost my life on [XXX] . I have personally read over 7300 online complaints of similar findings from not only Ford Ranger owners , but mechanics from private shops to Ford certified repair shops. Please , please, please contact Ford customer care, they will tell you there is a know issue that they agree poses a threat to drivers . Thank you very much . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
May 22, 2024
UNKNOWN OR OTHER,ENGINE
1 complaint
2019 Ford Rangers were shipped without an engine cover to protect the engine from water intrusion. This, along with the design of the plastic cowl at the base of the windshield being a 2 piece design with a seam directly over the engine bay, allows water to drain into the engine bay during periods of heavy rain. Water will drain from the windshield into the top of the engine, and begin filling the spark plug wells under the ignition coil boots and into the engine head. This water intrusion can cause engine misfire codes as well as a loss of power while driving, and on multiple instances while merging into traffic, the engine would bog down. It wasn't until the most recent occurrence that a check engine light came on. I immediately pulled into a shop and they found the plug wells were rusted, corroded and full of water from this happening since the day it rolled off the lot in 2019. I have had an independent mechanic assess the damage as well as had the vehicle towed to a local Ford dealer and they found the same condition- with the only solution to replace the engine head as they are unable to remove the plugs due to the damage caused by the water intrusion. An owner should not have to be concerned with parking or driving a vehicle in the rain and whether it will suddenly lose power while driving at highway speeds. This is a safety issue that Ford should be forced to take care of. They are aware of the issue and have been as they have issued multiple service bulletins with a solution for misfires to change plugs and install an engine cover. An engine cover has no bearing on an engine misfire but it shows Ford knows water is getting into engines and causing these problems. Engine/plugs/coils failed, it is available for inspection. Mine and public safety was at risk when driving as it lost power merging into traffic. Problem has been confirmed by dealer and independent mechanic. Last instance (2/9/24) was first time a CEL came on while driving
Mar 02, 2024
UNKNOWN OR OTHER,SERVICE BRAKES,FUEL/PROPULSION SYSTEM
1 complaint
Unintended Aceleration Veheicle experienced normal stop with no anomaly. Upon release of brakes, experienced reported Wide Open Throttle" Brakes were ineffective. Vehicle accelerate thru intersection striking guardrail with significant damage. WOT stopped by shutting of engine. Vehicle currently in repair. Reported event to local dealer service dept, Insurance Rep and Ford referencing 2010 Class Action Lawsuit for similar events, All claim no knowledge of such an event. Vehicle had no previous reports of similar events
Dec 22, 2023
ELECTRICAL SYSTEM,UNKNOWN OR OTHER,LANE DEPARTURE
1 complaint
Vehicle presented a blind spot system fault warning and a cross traffic system fault. Immediately after this warning appears the vehicle ac/ heater shutdown, passengers seat belts light came up and radio got frozen. None of the ac/ heater controls worked. Blinkers appears to be advising that the were not working properly. Vehicle rums but everything else regarding de console stopped working.
Oct 11, 2023
POWER TRAIN,UNKNOWN OR OTHER,ENGINE
1 complaint
The vehicle is shifting rough between 2nd and 3rd gear. It has trouble getting up to speed through intersections.
Aug 23, 2023
ELECTRICAL SYSTEM,EXTERIOR LIGHTING,LANE DEPARTURE
1 complaint
The blindspot sensor on my truck appears to have gotten very hot. It melted the tail light and the wiring harness.
Aug 02, 2023
SERVICE BRAKES, AIR
1 complaint
The contact owns a 2019 Ford Ranger. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed with an abnormal squealing sound. There were no warning lights illuminated. The vehicle was taken to an independent mechanic, who replaced the brake pads and brake discs. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 50,000.
Jul 27, 2023
POWER TRAIN,ELECTRICAL SYSTEM
1 complaint
The contact owns a 2019 Ford Ranger. The contact stated that the transmission was shifting roughly. While approaching a stop, there was an abnormal squealing sound detected from the tires, with the vehicle vibrating. The vehicle was randomly changing lanes while driving. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic who test drove the vehicle and confirmed that the vehicle had abruptly downshifted, and the tires were squealing. The contact called the local dealer, but the vehicle was not diagnosed. The manufacturer was not contacted. The failure mileage was approximately 50,000.
Apr 21, 2023
VISIBILITY,VISIBILITY/WIPER
1 complaint
Climate control temperature system failed and would not adjust. A clicking/snapping noise was present under the dash when attempting to control climate and defrost. Ford verified the failure of the climate control system and stated that I the original owner, [XXX], must personally pay for labor and parts to replace the climate control housing assembly to resolve the failed climate control system and achieve functional defrost. The vehicle went in for inspection at Jim Click Ford (6244 E 22nd St; Tucson AZ 85711; +1-520-570-7301) on the March 29th, 2023 and the repair was completed on April 4th, 2023 (Ford Part Number 18478). The vehicle had 29,634 miles on it at the time of repair. The issue is identical to that described in “SSM 49264: 2019-2020 – Climate Control Temperature Will Not Adjust With Clicking/Snapping Noise From The Dash – Built On Or Before 30-Jul-2020”. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Apr 06, 2023
ELECTRICAL SYSTEM,SEATS
1 complaint
The contact owns a 2019 Ford Ranger. The contact stated that while driving approximately 30-40 MPH, there was an abnormal burning odor detected. The contact stated that the front driver’s side heated seat had burned a two-inch hole into the seat, the upper back rest, and heating pad. The contact also noticed that the heated seat was inoperable. There were no warning lights illuminated. There were no blown fuses. The vehicle was taken to the dealer however, a service date was not available. The vehicle was not diagnosed or repaired. The contact repaired the seat himself. The manufacturer was notified of the failure and referred him to the local dealer for assistance. The failure mileage was approximately 54,000.
Mar 13, 2023
STEERING,SERVICE BRAKES
1 complaint
The contact owns a 2019 Ford Ranger. The contact stated that they had received a notification on the main control computer screen and the vehicle's notifications app indicated that there was an electrical failure occurring with the steering. The contact then stated at the same time the vehicle began to self-direct causing an excessive amount of force required to steer the vehicle. The brakes became difficult to depress causing an excessive amount of pressure to be applied on the brake pedal in order to get the vehicle to come to a stop. The vehicle was taken to the dealer who was unable to diagnose the cause of the failure. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 16,000.
Jan 09, 2023
STEERING,VEHICLE SPEED CONTROL,SERVICE BRAKES
1 complaint
The failed component is a small wheel speed sensor on the rear axle. The sensor is designed in a way where it inserts into the axle and sits close enough to the gears that it can be hit by the gears during bumps/potholes/etc. The issue puts myself and others at risk as when the sensor malfunctions or breaks, it disables multiple safety features of the truck including: Antilock brakes, traction control, power steering, hill assist, and collision avoidance system. Other systems affected include cruise control. The problem has been reproduced with three separate speed sensors, two OEM sensors and one after market. I have had the vehicle inspected by a Ford dealership for the issue. Issues prior to the first replaced sensor was the sensors have issues with cold climate. When snow or ice is on the roadway, the sensors have issues and disable all the above features. Appears the design cannot withstand the cold weather.
Nov 08, 2022
EXTERIOR LIGHTING,ELECTRICAL SYSTEM
1 complaint
The contact owns a 2019 Ford Ranger. The contact stated that the driver’s side rear taillight intermittently failed to illuminate while depressing the brake pedal. The contact also stated that the horn failed to operate as needed. The contact took the vehicle to a dealer where he was informed that his vehicle was not included in NHTSA Campaign Number: 19V839000 (Exterior Lighting). The manufacturer was notified of the failure and referred him to the dealer for assistance. The vehicle remained at the dealer unrepaired. The failure mileage was approximately 41,000.
Aug 02, 2022
UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM
1 complaint
Unknown, My vehicle seems to stall in low gear. I already informed the dealership several times, and they stated that everything was fine. The stalling appears to be getting more frequent as time goes on, and worried that this could cause further damage to the vehicle. This is a safety concern as well.
Mar 18, 2022
ENGINE,FUEL/PROPULSION SYSTEM,UNKNOWN OR OTHER
1 complaint
Drive truck and park in garage and garage smells like gas. Only happens when parking truck in garage right after driving it. This has happened about 3-4 times now. I don't drive it that often. Just had an oil change at Ford and drove home. Then the next day i took it out and parked it in garage and gas smell again. Smell will last 2-3 days if truck stays parked. Have an appt. this coming week at Ford.
Mar 12, 2022
FORWARD COLLISION AVOIDANCE
1 complaint
This is not the first time, but I will randomly get a collision warning while I am driving my car. The last incident happened on a 2 lane road with no traffic within visible distance in front of me. It was early in the morning with the sun ahead of the vehicle (approx 7am) and the collision warning indicator came on for no reason. This has happened before. Another incident occurred when I was turning right onto an on ramp and there was a car traveling next to me (who would continue straight) and the warning was going off for no reason. These incidents are extremely dangerous as the flashing and chiming from the alert system is very distracting and causes someone to react to this as opposed to focusing on driving the vehicle. For some people this could lead to a crash by itself as there is no training on what your vehicle will do in one of these situations (ie, like a push to test in an aircraft to know what is making the noise).
Feb 18, 2022
SERVICE BRAKES,FORWARD COLLISION AVOIDANCE
1 complaint
APPLYING BRAKE TRUCK WILL STOP, AFTER STOPING YOU FILL THE PADDLE MOVE DOWNWARD IN THE DIRECTION OF THE FLOORBOARD, AND THE TRUCK WILL START ROLLING UNTIL YOU APPLY MORE PRESSURE TO TH PADDLE..ACTING LIKE A BAD MASTER CYLINDER..2. CRASH LIGHT WILL FLASH, BUT NO BRAKING..THIS HAPPENS ABOUT EVERY TIME I DRIVE..
Dec 22, 2020
TIRES
1 complaint
TL* THE CONTACT OWNS A 2019 FORD RANGER EQUIPPED WITH BRIDGESTONE TIRES, TIRE LINE: DESERT DUELER II, TIRE SIZE: 255/65/17, DOT NUMBER: (UNAVAILABLE). THE CONTACT STATED THAT WHILE INSPECTING THE TIRES, HE NOTICED THAT THE SIDEWALL AND TREAD WAS SEVERELY DAMAGED. THE CONTACT STATED THAT THE TIRES WERE DRY ROTTED. MYERS FORD CO INC LOCATED AT 13959 SPOTSWOOD TRAIL, ELKTON, VA 22827, (540) 298-1271) WAS CONTACTED AND STATED THAT THE TIRES WERE DEFECTIVE AND REFERRED THE CONTACT TO THE MANUFACTURER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OPENED A CASE. THE MANUFACTURER DECIDED TO REPLACE ALL FOUR TIRES, DUE TO ALL FOUR TIRES SHOWING SIMILAR ISSUES. THE TIRES WERE REPLACED WITH SIMILAR BRIDGESTONE TIRES HOWEVER, THE FAILURE RECURRED WITH THE NEW SET OF TIRES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OPENED ANOTHER CASE REGARDING THE FAILURE. THE CONTACT WAS OFFERED A PRO-RATED COST FOR THE TIRE REPLACEMENT. THE TIRES WERE NOT YET REPLACED DUE TO THE CONCERNS OF THE CONTACT. THE APPROXIMATE FAILURE MILEAGE WAS 14,500. *DT
Oct 29, 2020
ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE
1 complaint
AFTER THE AUTO START STOP FEATURE ENGAGES AT A STOP, THE ENGINE BEGINS TO RE-START BUT THEN SHUTS DOWN COMPLETELY ALONG WITH ALL ELECTRIC FUNCTIONS IN THE VEHICLE. CANNOT ENGAGE HAZARD LIGHTS OR RE-START THE ENGINE UNTIL THE THE BATTERY IS JUMP-STARTED. ONCE THE VEHICLE IS JUMPED, IT FUNCTIONS NORMALLY AND DOES NOT DISPLAY ANY BATTERY OR CHECK ENGINE INDICATOR. THIS HAPPENED ONCE AT A STOP SIGN IN A RESIDENTIAL AREA, AND AGAIN AT A RED LIGHT ON A MULTI-LANE BOULEVARD WITH SPEED LIMIT 45 MPH.
Aug 12, 2020
UNKNOWN OR OTHER,VISIBILITY/WIPER
1 complaint
THE PASSENGER SIDE FRONT WINDOW IS DEVELOPING SEVERAL SNOWFLAKE LIKE DEFECTS IN BETWEEN THE GLASS. THESE ARE THREE TO FOUR INCHES IN DIAMETER AND IMPEDE THE SIDE VISION OF THE VEHICLE. FORD IS REFUSING TO REPLACE THE GLASS. THIS IS A SAFETY HAZARD AND NEEDS TO BE INVESTIGATED. THE SIZE GROWS AN 1/8 INCH A DAY AND DOES NOT STOP. THE SPOT IN THE PICTURE IS NEARLY DOUBLE IN SIZE NOW. *TR
Jun 09, 2020
POWER TRAIN,ELECTRONIC STABILITY CONTROL (ESC),ENGINE
1 complaint
SOMETIMES TRUCK STAYS IN GEAR AFTER SHIFTING INTO PARK. HAS ROLLED FORWARD AFTER I EXITED THE VEHICLE. LANE KEEP ASSIST HAS MISJUDGED LANE & TURNED THE WHEELS SHARPLY CAUSING UNWANTED LANE CHANGE. PRE COLLISION WARNING OFTEN SOUNDS ALARMS & SHOWS VISUAL WARNINGS WITH NO TRAFFIC NEARBY, THE SYSTEM HAS EMERGENCY BRAKING & I'M AFRAID OF IT APPLYING BRAKES WHEN I'M ON THE INTERSTATE. CRASH DETECTED AUDIBLE & VISUAL WARNINGS OFTEN APPEAR WHEN THERE HAS NEVER BEEN A CRASH. DRIVER'S DOOR MIRROR IS NOT SECURE, VIBRATES/RATTLES WHEN TRUCK IS AT HIGHWAY SPEEDS. FRONT & REAR DIFFERENTIALS MAKE GRINDING NOISES & FRONT END JUMPS, WHEELS LOCK UP WHEN USING 4X4L. DOES NOT ALWAYS SHIFT INTO 4X4H. VEHICLE HAS OVERHEATED & STALLED WHILE IN TRAFFIC. PEDESTRIAN DETECTION SYSTEM IS NON-FUNCTIONAL. A MAN STEPPED OFF THE SIDEWALK IN FRONT OF MY TRUCK ON MONDAY, JAN 06 2020, I WAS TRAVELING ABOUT 15-20 MPH. LUCKILY I SAW HIM IN TIME AND PUT THE BRAKES ON, WHEN I CAME TO A STOP THE MAN WAS A MERE 2" FROM THE FRONT OF MY TRUCK & WE WERE BOTH EXTREMELY SHAKEN. HAD I APPLIED THE BRAKES 1 SECOND LATER THE MAN WOULD BE DEAD. THE PEDESTRIAN DETECTION SYSTEM NEVER ALERTED ME TO THE PEDESTRIAN WITH ANY TYPE OF WARNING, AUDIBLE OR VISUAL. THE SYSTEM NEVER ASSISTED WITH EMERGENCY BRAKING AS A RESULT. THE PARKING & CROSS TRAFFIC SENSORS RARELY WORK CORRECTLY, ALMOST NEVER DETECT CROSS TRAFFIC WHEN PULLING OUT OF A PARKING SPOT. I CAN PULL UP TO A VEHICLE, WITH MY FRONT LICENSE PLATE TOUCHING THE RECEIVER BAR ON THE HITCH OF THE VEHICLE IN FRONT OF ME BEFORE THE SENSORS DETECT THE VEHICLE. AS A DISABLED VETERAN I'M MORE CAUTIOUS THAN MOST, BUT ALL OF THESE ISSUES, OF WHICH THERE ARE MORE, MAKE THIS TRUCK A SEVERE HAZARD, I DO NOT FEEL SAFE DRIVING IT. DEALERSHIP REFUSES TO SERVICE ANYMORE, HAS BEEN IN SHOP 5 TIMES, THEY HAVE WITNESSED SOME ISSUES BUT WON'T ACKNOWLEDGE THEM. UPLOADED LIST OF DEFECTS
Jan 10, 2020
VEHICLE SPEED CONTROL,ELECTRONIC STABILITY CONTROL (ESC)
1 complaint
THE TRUCK WILL DISPLAY A WARNING ON THE DASH AS WELL AS MAKE AUDIBLE WARNINGS SAYING THAT A CAMERA IN THE GRILLE IS BLOCKED OR MALFUNCTIONING. ANOTHER WARNING THAT ALSO HAPPENS A LOT IS SOMETHING SAYING THAT A CRASH HAS BEEN DETECTED, IT HAS LOUD CHIMES THAT GO OFF AS WELL AS A FLASHING RED DISPLAY ON DASH. THE PRE COLLISION WARNING ALSO FREQUENTLY ALERTS WITH VISUAL AND AUDIBLE WARNINGS. ALL OF THESE WILL HAPPEN AT ANY RANDOM TIME, AND OF ALL THE COUPLE DOZEN TIMES THESE WARNINGS HAVE HAPPENED THERE HASN'T BEEN A SINGLE TIME THAT THERE WAS ANY TRAFFIC NEARBY, NOR WAS THERE ANYTHING BLOCKING ANY CAMERA OR SENSOR. THE VEHICLE IS BARELY MORE THAN A MONTH OLD AND HAS BEEN BACK TO THE DEALERSHIP A FEW TIMES TO FIX BODY ALIGNMENT ISSUES AND PROGRAMMING ISSUES WITH THE ECU, PCM AND TCU. THE SERVICE DEPARTMENT TOLD ME THAT THE PRE COLLISION SYSTEM ONLY WORKS IF YOU ALSO HAVE ADAPTIVE CRUISE CONTROL, WHICH MY TRUCK DOES NOT. THEY SAID THERE IS NO WAY TO FIX THE SYSTEM TO GET IT TO STOP GIVING FALSE WARNINGS UNLESS THEY ADD THE ADAPTIVE CRUISE CONTROL MODULE AND OTHER COMPONENTS. HOWEVER, THE DEALERSHIP IS REFUSING TO ADD THE ADDITIONAL PARTS AND ALSO REFUSING TO REPLACE THE VEHICLE WITH ONE THAT DOES. THEY TOLD ME FORD IS AWARE OF THIS ISSUE, AND ADMITS THAT A FALSE WARNING MAY ACTIVATE THE BRAKING SYSTEM ON ITS OWN, WHICH CAN CAUSE AN ACCIDENT, BUT THEY STATED THAT FORD WILL NOT PAY CORRECT THE ISSUE. THIS IS A SERIOUS SAFETY ISSUE AND FORD NEEDS TO ISSUE A RECALL FOR THEIR FAULTY, AND DANGEROUS, COLLISION WARNING SYSTEM. THEY NEED TO INSTALL ADAPTIVE CRUISE CONTROL IN VEHICLES WITHOUT IF THAT'S ALL IT WOULD TAKE TO FIX THE ISSUE AND MAKE VEHICLES SAFE TO DRIVE.
Dec 14, 2019
SEATS,UNKNOWN OR OTHER
1 complaint
BACK SEAT BACK REST DOESN'T LOCK INTO PLACE
Oct 19, 2019
UNKNOWN OR OTHER,ENGINE,VISIBILITY/WIPER
1 complaint
I BOUGHT A 2019 FORD RANGER ON AUGUST 4, 2019 AND THE TRUCK VIBRATES SHAKES WHILE DRIVING AND THE WINDSHIELD WINDOW A LOUD NOISE LIKE AIR ITS COMING IN AND FEELS LIKE ITS GOING TO EXPLODE. THE MORE SPEED THE MORE VIBRATION AND NOISES IT MAKES. I DO NOT FEEL SAFE DRIVING THIS TRUCK AT ALL.
Oct 10, 2019
ELECTRICAL SYSTEM,UNKNOWN OR OTHER,SERVICE BRAKES
1 complaint
I WAS DRIVING MY VEHICLE AND TRYING TO STOP TO AVOID A COLLISION. THE SYSTEM INDICATED COLLISION DETECTION WAS ENGAGED; HOWEVER, THE BRAKES WOULD NOT STOP AND THERE WAS A WRECK.
Apr 04, 2019
POWER TRAIN,ELECTRICAL SYSTEM,SERVICE BRAKES
1 complaint
TAKATA RECALL- I WAS RECENTLY IN A CAR ACCIDENT WITH MY 2019 FORD RANGER AND WHEN I PRESSED THE BRAKE THE WOULD NOT APPLY SO I CONTINUED TO PUMP THE BRAKE AND WOULD NOT APPLY AS I APPROACHED THE OTHER VEHICLE THE PRECOLLISON ASSIST TURNED ON AND STILL NOTHING AS I HELD THE BRAKES DOWN CAUSING AN ACCIDENT
Apr 04, 2019
SEATS,SERVICE BRAKES
1 complaint
2019 FORD RANGER PURCHASED, NOTICED SLIGHT PULSATION WHEN STOPPING HIGHWAY OR CITY. CONTINUED TO GET WORSE TO A POINT WHERE I BECAME AFRAID TO DRIVE IT BECAUSE TWICE ON HEAVY BRAKING PULSATION WAS SEVER AND I WAS AFRAID WAS NOT GOING TO STOP. SITUATION WAS WORSE MORE TRUCK WAS DRIVEN. NOTIFIED SERVICE ADVISOR OF ISSUE AND THAT I HAD BEEN REALLY CAREFUL BUT THEN I NOTIFIED HIM AGAIN AND ADVISED I WAS FEARFUL OF DRIVING VEHICLE ESPECIALLY ON WET ROAD. TOOK PICTURE OF LEFT REAR ROTOR THRU WHEEL HOLES AND FOUND BLACK SPOTS IN ROTOR. TOOK TRUCK IN ON MARCH 19TH, SERVICE ADVISOR CALLED AND SAID THE MECHANIC WAS GOING TO HAVE ALL FOUR ROTORS TURNED. I TOLD HIM THAT WAS UNACCEPTABLE, THE ROTORS AND BRAKES NEED TO BE REPLACED. THE SITUATION WAS ESCALATED TO FORD MOTOR COMPANY, TODAY MARCH 26TH THE SERVICE ADVISOR CALLED AND LEFT MESSAGE THEY WERE REPLACING REAR ROTORS. HAVE NOT BEEN ABLE TO REACH THEM BACK BECAUSE I FEEL THEY NEED TO ALSO REPLACE BRAKE PADS, FOR A PROPER MATING PROCESS. HE NEVER MENTIONED FRONT ROTORS AGIN AS IN PREVIOUS DICUSSION. I ORIVINALLY ADVISED THEM THEY SHOULD REPLACE ALL ROTORS AND BRAKE PADS. THEM TELLONG ME THEY WERE GOING TO TURN ALL ROTORS MAKES ME THINK THAT ALL THE ROTORS ARE WARPED. ALSO REAR SEAT UPPER PORTION WHEN RELEASED TO DOWNWARD POSITION, IS VERY HARD TO RELOCK IN UPPER POSITION, WHICH IF NOT LOCKED TO CAUSE SEATBELTED PASSENGERS ND SEAT ITSELF TO FLY FORWARD IN A FRONTAL CRASH.
Mar 26, 2019
Where to Find VIN for Problems Check
To check for problems and complaints on your 2019 FORD Ranger, you'll need the VIN number. Find your VIN in one of these 4 common locations.
Understanding VIN Structure for Problem Reports
Each character in your 2019 FORD Ranger 17-digit VIN helps identify specific complaints and problems affecting your vehicle model.
How to Check 2019 FORD Ranger Problems in 3 Steps
1
Locate Your VIN
Find the 17-character VIN on your 2019 FORD Ranger dashboard (visible through windshield), door jamb, engine bay, or vehicle documents.
2
Review by Component
Browse owner-reported complaints organized by vehicle component (engine, transmission, brakes, electrical) to identify common issues and problem patterns for this model year.
3
Check Safety Issues
Review crash and fire incidents for each component to assess safety concerns. Contact your FORD dealer or report problems to NHTSA at SaferCar.gov.
Frequently Asked Questions
How many problems does the 2019 FORD Ranger have?
The 2019 FORD Ranger currently has 237 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.
What are the most common problems with 2019 FORD Ranger?
The most common problems reported for the 2019 FORD Ranger are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.
Where does this 2019 FORD Ranger problem data come from?
All problem and complaint data for the 2019 FORD Ranger comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.
How do I report problems with my 2019 FORD Ranger?
You can report safety problems with your 2019 FORD Ranger directly to NHTSA at SaferCar.gov or call 1-888-327-4236. Your complaint helps identify patterns and may lead to recalls or investigations.
Where can I find my VIN to check problems?
Your 2019 FORD Ranger VIN is located in 4 places: (1) Dashboard near windshield on driver's side, (2) Driver's door jamb sticker, (3) Engine bay, (4) Vehicle registration and insurance documents.
Is the 2019 FORD Ranger reliable?
Reliability can be assessed by reviewing the number and severity of owner complaints for the 2019 FORD Ranger. Check complaints by component, crash reports, and fire incidents above to evaluate potential issues and problem patterns.
Other Years - FORD Ranger Problems
2025
2024
2023
2022
2021
2020
2018
2017
2016
2015
2014
2013
2012
2011
2010
2009
2008
2007
2006
2005
2004
2003
2002
2001
2000
1999
1998
1997
1996
1995
1994
1993
1992
1991
1990
Other FORD Models
'34
1500 Foldaway
A8513
A9513
A9522
Aerostar
Affordable Aluminum
Affordable Trailers
Aspire
AT8513
AT9513
AT9522
Similar Brands
ST
3,555 models
RS
3,484 models
NC
2,822 models
ND
2,385 models
Z
1,951 models
MOTO
1,583 models
NU
1,189 models
RC
1,122 models