2005 HONDA Odyssey Recalls & Safety Issues
Official recalls, technical service bulletins (TSBs), and safety issues from the National Highway Traffic Safety Administration (NHTSA).
9
Recalls Found
All Recalls
Delphi Automotive Systems, LLC (Delphi) is recalling certain replacement fuel pump modules, part number FG1155-11B1, sold for use in 2005-2010 Honda Odyssey vehicles. The affected fuel pump may send an incorrect fuel reading to the fuel gauge possibly causing the vehicle to run out of fuel. The fuel gauge will always read 3/4 full to full regardless of the actual level.
NHTSA 14E049000
Consequence: A vehicle that runs out of fuel and stalls has an increased risk of a crash.
Remedy / Corrective Action
Delphi has begun notifying dealers and distributors, and will replace the fuel pump modules, free of charge. Owners may contact Delphi customer service at 1-877-411-8770. Delphi's number for this recall is GL14-004.
American Honda Motor Co., Inc. (Honda) is recalling certain 2005-2010 Honda Odyssey vehicles manufactured June 23, 2004, through September 4, 2010. In the affected vehicles, the fuel pump strainer cover may deteriorate allowing fuel to leak out.
NHTSA 14V112000
Consequence: A fuel leak increases the risk of a fire.
Remedy / Corrective Action
Parts to permanently repair the affected vehicles are not currently available. Honda will notify owners with an interim letter during May 2014. A second notice was mailed to owners October 6, 2014 when the remedy became available. Any vehicles that are currently leaking from the fuel pump cover will get a replacement, original cover. All vehicles, including those receiving the interim repair, will get an improved cover when they are available. Owners may contact Honda at 1-800-999-1009. The recall numbers associated with this campaign are JD9 (inspection and/or preliminary part replacement) and JE0 (final parts replacement).
HONDA IS RECALLING CERTAIN MODEL YEAR 2005-2007 ODYSSEY AND ACURA RL VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS A LUBRICANT FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.
NHTSA 10V504000
Consequence: A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.
Remedy / Corrective Action
DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER SEAL FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2010. OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
HONDA IS RECALLING CERTAIN MODEL YEAR 2005 ODYSSEY TOURING VEHICLES EQUIPPED WITH POWER OPERATED REAR LIFTGATE. THE POWER LIFTGATE GAS STRUTS MAY DETERIORATE UNEXPECTEDLY EARLY. STRUTS THAT HAVE WORN OUT PREMATURELY MAY FAIL TO HOLD THE POWER LIFTGATE IN THE FULLY OPEN POSITION, CAUSING THE POWER LIFTGATE TO CLOSE UNEXPECTEDLY.
NHTSA 10V055000
Consequence: INJURY MAY RESULT FROM A POWER LIFTGATE CLOSING UNEXPECTEDLY WHEN A PERSON IS WITHIN THE CLOSING PATH OF THE LIFTGATE.
Remedy / Corrective Action
DEALERS WILL INSPECT THE GAS LIFTGATE STRUTS AND REPLACE IF WITHIN THE RECALL POPULATION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE CAMPAIGN BEGAN ON MARCH 26, 2010. OWNERS MAY CONTACT HONDA AUTOMOBILE CUSTOMER SERVICE AT 1-800-999-1009.
ON CERTAIN MINIVANS AND SPORT UTILITY VEHICLES, THE STEERING COLUMN MAY BE INCORRECTLY ASSEMBLED, WHICH COULD RESULT IN A LOSS OF STEERING CONTROL.
NHTSA 05V039000
Consequence: LOSS OF STEERING CONTROL CAN CAUSE A VEHICLE CRASH WITHOUT PRIOR NOTICE.
Remedy / Corrective Action
OWNERS WERE NOTIFIED BY TELEPHONE ON JANUARY 25, 2005, AND ARRANGEMENTS WERE MADE TO HAVE THEIR VEHICLES TOWED TO THEIR DEALERS AND HAVE THE REPAIRS PERFORMED. THE RECALL BEGAN ON JANUARY 25, 2005.
ON CERTAIN PASSENGER VEHICLES, A LOOSE TERMINAL IN THE MAIN FUSE BOX MAY CAUSE THE FUEL PUMP TO LOSE POWER. IF THE FUEL PUMP BECOMES INOPERATIVE, THE ENGINE MAY NOT START.
NHTSA 05V132000
Consequence: IF THE FUEL PUMP LOSES POWER WHILE DRIVING THE ENGINE COULD STALL WITHOUT WARNING WHICH COULD RESULT IN A CRASH.
Remedy / Corrective Action
DEALERS WILL REPLACE THE ENTIRE FUSE BOX FREE OF CHARGE. THE RECALL BEGAN ON APRIL 13, 2005. OWNERS MAY CONTACT HONDA AT 800-999-1009 OR ACURA AT 1-800-382-2238.
THE FRONTAL AIR BAG SYSTEM HAS TWO EXTERNAL IMPACT SENSORS. ON CERTAIN MINI VANS,SOME SENSORS WERE INSUFFICIENTLY SEALED DURING MANUFACTURING. IF WATER ENTERS A SENSOR, CORROSION CAN OCCUR. CORRODED SENSORS COULD SHORT CIRCUIT INTERNALLY. IF SENSORS FAIL, THE SRS WARNING LAMP ON THE INSTRUMENT PANEL WILL TURN ON AND REMAIN ILLUMINATED.
NHTSA 05V344000
Consequence: FRONT IMPACT SENSOR FAILURE COULD CAUSE A DELAY IN, OR LOSS OF, FRONTAL AIR BAG DEPLOYMENT, WHICH CAN INCREASE THE RISK OF INJURY IN A FRONTAL CRASH.
Remedy / Corrective Action
DEALERS WILL REPLACE THE FRONT IMPACT SENSORS. THE RECALL BEGAN ON AUGUST 30, 2005. OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
ON CERTAIN VEHICLES, A COIL WIRE INSIDE THE FUEL PUMP RELAY MAY BREAK, CAUSING THE FUEL PUMP TO LOSE POWER. IF THE FUEL PUMP BECOMES INOPERATIVE, THE ENGINE MAY NOT START.
NHTSA 07V097000
Consequence: IF THE FUEL PUMP LOSES POWER WHILE DRIVING, THE ENGINE COULD STALL WITHOUT WARNING, AND A CRASH COULD OCCUR.
Remedy / Corrective Action
DEALERS WILL INSPECT AND REPLACE THE FUEL PUMP RELAY FREE OF CHARGE. THE RECALL BEGAN ON APRIL 2, 2007. OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
ON CERTAIN MINIVANS, THE ANTI-LOCK BRAKE SYSTEM (ABS) USES A SENSOR ON EACH WHEEL TO DETECT WHEEL SPEED. SOME SENSORS ON THE REAR WHEELS WERE INSTALLED INCORRECTLY, WHICH MEANS THE SENSOR MAY REPORT THE WRONG WHEEL SPEED TO THE ABS CONTROL UNIT.
NHTSA 04V536000
Consequence: THE DRIVER COULD EXPERIENCE A LOSS OF BRAKE FORCE AND A CRASH COULD OCCUR.
Remedy / Corrective Action
DEALERS WILL INSPECT THE REAR WHEEL SPEED SENSORS. IF AN INCORRECT GAP IS DETECTED, THE SENSOR WILL BE REMOVED AND THE KNUCKLE CHECKED FOR CROSS THREADING DAMAGE. IF DAMAGE IS FOUND, THE KNUCKLE WILL BE REPLACED. IF NO DAMAGE IS FOUND, THE SENSOR WILL BE REINSTALLED CORRECTLY. THE RECALL BEGAN ON NOVEMBER 12, 2004. OWNERS SHOULD CONTACT HONDA AT 1-800-999-1009.
Frequently Asked Questions
How many recalls does the 2005 HONDA Odyssey have?
The 2005 HONDA Odyssey currently has 9 recalls according to NHTSA records. All recall information is sourced directly from the National Highway Traffic Safety Administration database.
Are 2005 HONDA Odyssey recalls free to fix?
Yes! All safety recalls for 2005 HONDA Odyssey vehicles must be repaired free of charge by authorized dealers, regardless of vehicle age or mileage. Contact your local HONDA dealer to schedule a recall repair.
How do I check if my 2005 HONDA Odyssey has open recalls?
You can check for open recalls by entering your VIN (Vehicle Identification Number) in our VIN decoder tool. The 17-character VIN can be found on your vehicle registration, insurance card, or on the driver's side dashboard visible through the windshield.
Other Years - HONDA Odyssey
2004 Recalls
2003 Recalls
2002 Recalls
2001 Recalls
2000 Recalls
1999 Recalls
1998 Recalls
1997 Recalls
1996 Recalls
1995 Recalls
Other HONDA Models
A1
Accord
Accord Crosstour
ADV150
ADV160
AFRICA TWIN
ATC250
ATC350X
C125 (Super Cub)
CB-1
CB1000
CB1000R
CB1000RA
CB1100
CB1100A
CB1100SA
CB125
CB250 (Nighthawk)
CB300
CB300F
Similar Brands
IVECO
10 models
NABI
5 models
SUBARU
24 models
HINO
33 models
MONACO
4 models
RIVIAN
4 models
COACHMEN
1 models
RANGER
5 models
PIAGGIO
40 models
CHEVROLET
123 models