2003 HONDA VFR800 Problems

VIN Decoder

Premium Report

Complaints Reported

Radar Detector GPS Tracker OBD2 Scanner Car Refrigerator Jump Starter Dash Cam

As an Amazon Associate, ForCar.org earns from qualifying purchases.

Complaints by Component

ELECTRICAL SYSTEM

6 complaints

TL*THE CONTACT OWNS A 2003 HONDA VFR800. WHILE RIDING 70 MPH, THE HEADLIGHT SHUT OFF WITHOUT WARNING. THE CONTACT BELIEVED THAT THE FRONT FAIRING SUB-HARNESS TRANSFERRED THE ELECTRICAL GROUNDING LOAD OF THE HEADLIGHT TO OTHER COMPONENTS AND CAUSED THE FAILURE. NHTSA CAMPAIGN ID NUMBER 07V359000 (ELECTRICAL SYSTEM:WIRING) WAS REFERENCED. THE DEALER HAS NOT INSPECTED THE VEHICLE. THE POWERTRAIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 27,239.

Sep 05, 2007

2003 HONDA VFR MOTORCYCLE SHUT OFF WHILE OPERATING AT APPROX. 30 MPH / 3500 RPM. SAFELY PULLED OFF ROAD AND PARKED. HEADLIGHTS & DASHBOARD LIGHTS DIM, BUZZING SOUND FROM DASHBOARD. BIKE RESTARTED ONLY WHEN HEADLIGHT FUSE WAS REMOVED. BIKE CURRENTLY AT HONDA DEALER FOR REPAIRS. EXTENSIVE DISCUSSION OF THIS PROBLEM, SOLUTION, AND ELECTRICAL SYSTEM DESIGN FLAWS IN NUMEROUS 6TH GENERATION (2002 - 2007) VFRS AVAILABLE AT "HTTP://WWW.VFRDISCUSSION.COM/FORUM/INDEX.PHP?SHOWFORUM=2" (1ST THREAD). SOLUTIONS INCLUDE ADDITIONAL ELECTRICAL GROUNDS, HEAVIER GAUGE WIRING &/OR HEAVIER DUTY FUSE HOLDERS. THIS IS A LIFE THREATENING DESIGN FLAW! IF THE BIKE WERE TO SHUT DOWN AT HIGH SPEED, IN HEAVY TRAFFIC, UNDER DEMANDING ROAD CONDITIONS, ETC, A SEVERE CRASH WOULD BE VERY LIKELY. PLEASE ENCOURAGE HONDA TO ISSUE A RECALL TO CORRECT THIS PROBLEM IMMEDIATELY. *TR

Jul 10, 2007

REGARDING INVESTIGATION PE05047 THIS INVESTIGATION WAS CLOSED 12/20/05, BUT I HAVE READ MANY COMPLAINTS FROM OWNERS OF THIS MODEL THAT ARE HAVING THE SAME PROBLEM. MY HONDA VFR800 SHOWS SIGNS OF FAILURE DURING NORMAL USE AND THERE ARE NO "MODIFICATIONS TO THE WIRING HARNESS" AS SUGGESTED BY YOUR INVESTIGATION. THE ONLY AUXILIARY LOADS I HAVE ON MY BIKE ARE CONNECTED BY SEPARATE HARNESS DIRECTLY TO THE BATTERY AND THEREFORE BYPASS THE MAIN WIRING HARNESS. YET A CABLE, FUSE BLOCK AND A CONNECTOR ON THE FACTORY HARNESS DIRECTLY ATTACHED TO THE BATTERY GET HOT TO THE TOUCH IN NORMAL USE. SEVERAL OWNERS HAVE REPORTED THAT THEY HAD TO MAKE SEVERAL ATTEMPTS AT HAVING THE HONDA DEALERS ADMIT TO THE PROBLEM, AND THAT THE FACTORY NEVER DID, YET AFTER SUFFICIENT COMPLAINTS REPLACED THE ENTIRE WIRING HARNESS WITH AN UPGRADED MODEL. I WOULD THINK THAT THIS KIND OF FAILURE (MELTED WIRING INSULATION, BURNT FUSE BLOCK, MELTED CONNECTORS) WOULD CONSTITUTE A SAFETY HAZARD AND THAT NHTSA AND HONDA WOULD WANT TO RESOLVE THIS MORE PROACTIVELY. *NM

Jan 07, 2006

DT: THE CONTACT STATED THE ELECTRICAL SYSTEM BURNED. THIS CAUSED THE HEADLIGHTS NOT TO WORK. THE CONTACT NOTICED THE PROBLEM WHEN HE PURCHASED THE VEHICLE, AND TOOK IT TO A LOCAL DEALERSHIP, WHO HAD THE ELECTRICAL SYSTEM REPLACED UNDER WARRANTY. THE DEALERSHIP STATED IT WAS BECAUSE OF THE PREVIOUS OWNER'S NEGLIGENCE. *AK

Nov 14, 2005

MOTORCYCLE HEADLIGHTS INTERMEITTENTLY TURN OFF. ELECTRICAL PROBLEM ALSO RESULTING IN MOTORCYCLE TURNING OFF DURING OPERATION. REFERE TO THIS WEB SITE FOR MANY DETAILS: HTTP://WWW.VFRDISCUSSION.COM/FORUM/INDEX.PHP?SHOWTOPIC=6856&HL=MY+FIRST+ELECTRICAL+PROBLEM

Jun 17, 2005

+ 1 more complaint for this component

ELECTRICAL SYSTEM,EXTERIOR LIGHTING

1 complaint

MY ISSUE WAS FIRST DISCOVERED IN 2012 WHEN I COULD NOT START MY MOTORCYCLE; MY FIRST THOUGHT WAS AN OLD BATTERY. UPON RESEARCHING ON VFRDISCUSSION.COM I WAS EXPOSED TO NUMEROUS VFR OWNERS WITH STARTING ISSUES THAT WAS RELATED TO THE ELECTRICAL AND CHARGING ISSUES, A KNOWN ISSUE WITH MY 2003 MODEL YEAR. FROM THE INFORMATION GATHERED I STARTED TO INVESTIGATE MY MOTORCYCLE TO SEE IF THE ISSUE IS INDEED TRUE. I DID A SERIES OF SUGGESTED ELECTRICAL TESTING WITH A MULTIMETER AND THE RESULTS PROVE NEGATIVE. I PROCEEDED TO REMOVE THE PLASTIC COVERING TO EXPOSE WIRING TO SEE IF I HAVE BURNT CONNECTORS AND WIRING, WHICH I DO. I HAD THE ELECTRICAL SYSTEM REPAIRED WITH NEW STATOR, REGULATOR/RECTIFIER AND BATTERY. AFTER THE REPAIR I WAS ABLE TO RIDE FOR THE SEASON. MY BATTERY WAS CHARGING, ELECTRICAL SYSTEM WAS GOOD, NO ISSUES. NOW IN 2013 I AM HAVING THE SAME CHARGING ISSUE AGAIN. THE BATTERY IS NOT CHARGING, NOT ABLE TO START THE MOTORCYCLE. MY CONCERN HERE IS THAT AMERICAN HONDA IS NOT BEING PROACTIVE ABOUT THEIR PRODUCT ISSUE. THERE ARE NUMEROUS VFR800 OWNERS WITH SIMILAR ELECTRICAL ISSUES, ISSUES LIKE BURNT STATOR AND WIRING/ CONNECTORS. THIS ELECTRICAL ISSUE HAS LEFT ME STRANDED FAR FROM HOME. PLEASE ADDRESS THIS ISSUE. THANK YOU. *TR

Apr 23, 2013

FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM

1 complaint

DT: THE CONSUMER EXPERIENCED AN ELECTRICAL PROBLEM, THERE IS A BUZZING NOISE COMING FROM THE FRONT OF VEHICLE, ONE OF THE WIRES COMING FROM THE BATTERY BECAME HOT, CAUSING IT TO MELT. THE FUEL PUMP DOES NOT WORK, CAUSING VEHICLE NOT START, VEHICLE SHUTS OFF AT HIGHER SPEEDS, CONSUMER TOOK VEHICLE TO DEALER, WHO TRIED TO FIX PROBLEM, BUT PROBLEM RECURRED. *AK *SC *JB

Jul 08, 2005

4.6/5.0

33 reviews

Where to Find VIN for Problems Check

To check for problems and complaints on your 2003 HONDA VFR800, you'll need the VIN number. Find your VIN in one of these 4 common locations.

Where to Find VIN Number on 2003 HONDA VFR800 for Problems Lookup - Dashboard, Door Jamb, Engine Bay, Documents

Understanding VIN Structure for Problem Reports

Each character in your 2003 HONDA VFR800 17-digit VIN helps identify specific complaints and problems affecting your vehicle model.

2003 HONDA VFR800 VIN Structure for Complaint Verification - WMI, VDS, Check Digit, Model Year, Plant Code

How to Check 2003 HONDA VFR800 Problems in 3 Steps

Locate Your VIN

Find the 17-character VIN on your 2003 HONDA VFR800 dashboard (visible through windshield), door jamb, engine bay, or vehicle documents.

Review by Component

Browse owner-reported complaints organized by vehicle component (engine, transmission, brakes, electrical) to identify common issues and problem patterns for this model year.

Check Safety Issues

Review crash and fire incidents for each component to assess safety concerns. Contact your HONDA dealer or report problems to NHTSA at SaferCar.gov.

Frequently Asked Questions

How many problems does the 2003 HONDA VFR800 have?

The 2003 HONDA VFR800 currently has 8 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2003 HONDA VFR800?

The most common problems reported for the 2003 HONDA VFR800 are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2003 HONDA VFR800 problem data come from?

All problem and complaint data for the 2003 HONDA VFR800 comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.

How do I report problems with my 2003 HONDA VFR800?

You can report safety problems with your 2003 HONDA VFR800 directly to NHTSA at SaferCar.gov or call 1-888-327-4236. Your complaint helps identify patterns and may lead to recalls or investigations.

Where can I find my VIN to check problems?

Your 2003 HONDA VFR800 VIN is located in 4 places: (1) Dashboard near windshield on driver's side, (2) Driver's door jamb sticker, (3) Engine bay, (4) Vehicle registration and insurance documents.

Is the 2003 HONDA VFR800 reliable?

Reliability can be assessed by reviewing the number and severity of owner complaints for the 2003 HONDA VFR800. Check complaints by component, crash reports, and fire incidents above to evaluate potential issues and problem patterns.