2025 TOYOTA RAV4 Problems

Complaints Reported

Complaints by Component

UNKNOWN OR OTHER

6 complaints

El día 2 de octubre compré una Rav 4 2025.El día 14 de octubre me doy cuenta que los cristales se encontraban rayados como por dentro del cristal, entiendo que esto pudo haber puesto en riesgo mi seguridad ya que si cualquiera de los cristales se rompe puede cortarme a mi o a un pasajero. En la primera inspección no notaron nada luego llamaron a un especialista de Toyota para verificarlo y en conclusión si noto dicho defecto en los cristales pero noto que en el mismo concesionario había varios vehículos con el mismo problema me notificó que su deber es reportar este problema pero que por el momento no hay nada que hacer con mi auto estos rayones por dentro del cristal únicamente son vistos específicamente bajo los rayos de la luz solar.No hubo ningún símbolo ni falla antes de notarlo el día 14 de octubre2025

Nov 12, 2025

The vehicle's CarPlay is malfunctioning, showing incorrect vehicle location and navigation directions. The vehicle's screen often shows incorrect location and directions, and changes directions as it updates where it thinks the car is. This is available for inspection upon request. The safety of the driver and passengers is put at risk because the screen showing incorrect location and directions causes a constant distraction, taking your eyes away from the road to figure out if the map is showing you the correct location or not. Sometimes, when the carplay is looking for the correct location, the map spins around and shifts location which is also distracting even when you try to ignore it. The consistent distraction this causes while trying to navigate through unknown streets has caused both my wife and I to get lost, take the wrong turns, or get stressed and confused while driving because we don't know what the directions are telling us, or we don't know if we are following the right directions. We are worried we will hit a car or person during these times of confusion. This has been repeated multiple times at Toyota dealership and is a known issue acknowledged by Toyota corporate. The vehicle has been inspected by Toyota's regional technician who installed an unreleased software update at my last visit, but the problem persists without improvement. There isn't a warning sign. I have requested a replacement or reimbursement for this vehicle from Toyota but their Dispute Resolution team says I have not given enough opportunity for Toyota to repair the car. I then brought the car back in and they kept it for three weeks and installed an unreleased software update. The loaner car they provided me was the same car different year and had no carplay issues. I am trying to bring it back but the dealership cancelled my appointment telling me they won't accept the car because they can't fix it. I am trying to escalate again to corporate.

Nov 04, 2025

During an AWS outage on 10/20/2025, the connect app which can turn on or off the vehicle, unlock/lock doors, etc had issues where it performed an unlock on our vehicle 5 times in 24hrs without us doing anything. Key fob was in sleep mode / low power mode (cannot signal vehicle). Reports of this happening to others found online, but Toyota dealership states no reports on any of this happening.

Oct 21, 2025

I was driving on CA Highway 20 on Thursday afternoon, Oct. 2, when the sunroof spontaneously shattered. I was not driving under a bridge or overpass or tree. There were no vehicles directly in front of me. I heard a loud pop, like an exploding bottle, but could see no damage inside the car. Within a few miles, glass was flying off the roof and striking cars behind me. That's when I pulled off the road and saw the roof was shattered. The shape of the break mounded up in the middle, implying the roof had broken upward. There were no rocks inside on the sunroof cover, nor any other debris than shattered glass.

Oct 04, 2025

Unintended/unwanted sudden acceleration - we are aware of this happening 5 times while I was driving, all times coasting to proceed into a turn. (I DO NOT DRIVE WITH 2 FEET). In each instance, while coasting my right foot covered (above) the brake pedal. BOTH feet were off the gas and brake pedal. Tachometer suddenly and rapidly spiked and car appeared/sounded like it would surge forward. In hopes of avoiding this sudden surge forward, I quickly put car in neutral and applied brake. Car slows and tachometer returns to normal. Brought to dealer, they stated from black box inspection that I was applying brake and gas simultaneously. THIS IS NEARLY IMPOSSIBLE FOR ME; as I demonstrated to folks at dealer I physically cannot do this without causing the arthritic pain in my ankle/foot to rise to a very noticeable level. The pain would be prolonged while doing what they claimed I was doing. I vehemently deny their explanation for these occurrences. No accidents occurred, nobody was injured (in these incidents). Obviously those in my car and others near my vehicle on the road should this happen again could be injured. No warning lights, messages etc were displayed. Sporadic occurrences. Purchased vehicle July 11,2025, first occurrence (I noticed) at July 31, 2025. Dealer stated their case is closed on this as of 9/04/25. Today 9/17/25 another occurrence happened. Car is available for inspection upon request.

Sep 17, 2025

+ 1 more complaint for this component

VISIBILITY/WIPER

3 complaints

Unknow

Dec 18, 2025

Stress fracture in the windshield

Nov 19, 2025

The windshield is warped and distorted. The dealership also told me that they can also see the warp in it. The original windshield was replaced, and the new one also has the same issue. The brand engagement rep I spoke with at Toyota told me that he has received multiple calls about the windshield issue. This vehicle was purchased 7/30/2025, and only has 271 miles on it and is on the original tank of gas. I have to rely on other people to give me rides places, as I am unable to drive this vehicle. The safety risk is due to the dizziness, nausea and migraine it causes me to drive it. My eyes feel like they are going cross eye, and I have to look out the driver's side window to get any kind of relief, which isn't allowing me to be alert while driving. This causes a huge issue for my safety as well as others. The Toyota Brand engagement rep that I spoke with said it is an issue and he has received multiple calls about it. The dealership has also acknowledged that they were able to see the defect.

Nov 10, 2025

STRUCTURE

3 complaints

I discovered early rust formation on my vehicle shortly after purchase. The dealership only proposed painting over the rust instead of investigating the underlying cause. This may indicate a factory-related structural defect and could pose a long-term safety risk. I am requesting an investigation.

Nov 21, 2025

The power rear liftgate will close on a person or object and cannot be stopped except if one presses on a very specific part of the edge of the liftgate, towards its center. This happens no matter how much upward force is applied to the area of the pull handles and the edges. When my wife pulled the handle, the liftgate closed with force that she could not resist. This obviously creates a serious safety hazard for small children, pets, or really anyone trying to close the liftgate or who may have inadvertently hit the button or pulled the handle.

Nov 06, 2025

I noted the body is made up of soft materials that slightly bend when push lightly with hand. I put a magnet to see if it’s made up of metal but noted a weak attraction of the magnet to the body. When I used my buttock to push the door to close ( my hands were not free and held several grocery bags), my buttock sunk to the part of the area I pressed on. I heard and felt the bending and clicking sound of plastic then it lifted back to its shape. I almost lost my balance since I’m not expecting the door that soft. I was scared that I dented the door. So how safety is this 2025 RAV4 ? We also have 2023 RAV4 of same model XLE AWD Premier. I wonder what will happen if it has accident with another vehicles on the road. With this body materials will save me from any kind of collisions ? I just noticed this brought by my experience today.

Aug 17, 2025

SERVICE BRAKES

2 complaints

I rented the Toyota RAV4 from Fox Rent a Car (855 571-8414) at the Denver International Airport for a trip to Boulder, CO. On November 9 evening, I drove to the Sugarloaf Mountain Trail Head (GPS: 40.05, -105.425) for a time-lapse photography. Date/Time: 2025-11-09 6:29 PM Location Description: Uneven dirt parking area commonly used by sightseers. Visibility was completely dark at the time of arrival. After arriving at the hilltop, as I parked the vehicle, while applying very light pressure to the accelerator pedal with my right foot, I felt a gradual drop of several inches on the passenger side of the vehicle. Instinctively, I moved my right foot to the brake pedal and applied pressure. However, I immediately sensed that the vehicle was not decelerating; instead, it was accelerating forward. I pressed the brake pedal more firmly, and the vehicle accelerated further until it came to a complete stop after colliding with a rock on the driver's side approximately 15 feet from the point of initial acceleration. Once the situation stabilized, I exited the vehicle and observed a red, non-oily liquid of normal viscosity leaking from underneath the vehicle on the front driver's side, which I later identified as coolant. Upon opening the hood, I confirmed that approximately half of the coolant had been depleted. I Googled AI Mode: Question: For a Toyota RAV4 HEV, is it possible for the vehicle to accelerate when the brakes are applied forcefully and abruptly? Answer (Source): [XXX] Potential Perceptions and Known Issues While the car will not accelerate due to the brakes being applied correctly, drivers have occasionally reported sensations that might be might be misinterpreted as acceleration, such as a slight "lurch" when the braking system transitions between regenerative and friction braking, ** especially at very low speeds or over rough surfaces. ** INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Nov 12, 2025

Crash: 1

Stopped to allow a car to pass. Once the car passed, there was acceleration of the engine but the car would not move. When the car gear was changed to park and then back to drive, it would not move. In order to get the car out of the traffic lane, the car was placed in neutral but the car brakes were locked. All this time the red 'park' on the dash and the red button on the console kept flashing. We called AAA and they arrived in 40 minutes. The man got in the car and stated they sometimes reset themselves. The car did start and he was able to drive it as the brakes were no longer locked. We took it to Toyota of Orange but they were unable to find the cause. They stated that they elevated this incident to a test case. TA252650358 This car only has 2,689 miles on it !!

Sep 26, 2025

ELECTRICAL SYSTEM

2 complaints

component: main engine wiring harness. cause: rodent caused damage: the rodent severely damaged this component and made the vehicle inoperable. fix: required the replacement of this component. insurance covered the 8,500 repair bill (minus deductible). a check engine light appeared eventually.

Oct 21, 2025

The contact owns a 2025 Toyota Rav4. The contact stated that upon leaving the keys in the ignition overnight, the battery was drained. The contact stated that the jumper cables were in a compartment located inside the trunk. The contact stated that due to the battery failure, the contact was unable to unlock the vehicle. In addition, there was no keyhole for the trunk of the vehicle. The contact entered the trunk through the inside of the vehicle; however, the compartment where the jumper cables were located had failed to open due to the battery failure. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the NHTSA Hotline to file a complaint. The vehicle was not repaired. The failure mileage was approximately 5,500.

Sep 15, 2025

TIRES

2 complaints

The contact owns a 2025 Toyota Rav4 equipped with Michelin Tires, Tire Line: Primacy A/S, Tire Size: 225/60/R16, DOT Number: (N/A). The contact stated while driving 70 MPH, the rear passenger’s tire detached from the rim. The contact stated that the failure had occurred while driving on a three-lane highway. The vehicle was driven over to the shoulder of the roadway. The contact inspected the vehicle and noticed that the passenger’s side rear tire had detached from the rim. Roadside Assistance was contacted and replaced the wheel with the spare tire. The manufacturer was made aware of the failure but provided no assistance. The contact was advised that without a part of the tire, no assistance would be provided. The failure mileage was approximately 7,000.

Oct 08, 2025

I was driving on the Highway at 70 mph and the rear passenger tire blew out. Thank God I was able to stopped the car safely and no one was injured. It was a scary moment and it is still is.My safety and other was at risk It is a brand new car with only 4397 miles. I took the car to the dealership and they replaced the tire. They found NO indications of a puncture or road hazard. Tire split at the shoulder and sidewall. Tire description Dunlop Grantrek 225/60 R 18

Jul 27, 2025

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,WHEELS

1 complaint

The front camera fails which does not allow for the cruise control to operate. The speed odometer does not specify the correct speed when driving the car. The feature of telling you how fast you are supposed to go does not operate correctly specifying the wrong speed you are supposed to go. The tires have already been replaced because the metal was coming out of the tires causing the car to not operate correctly there was wobbling in the tires causing the car to feel like the tires were about to come off the tires. The transmission not shifting properly in eco mode.

Dec 16, 2025

ELECTRICAL SYSTEM,ENGINE

1 complaint

Formal Complaint to Toyota Motor Corporation (Manufacturing) Regarding: Serious Manufacturing Defect and Failure of New Vehicle Safety Customer: [XXX] Customer Contact: Phone – [XXX] | Email – [XXX] Vehicle Purchased: (New/Recently Purchased Toyota Model) Date of Purchase: [XXX] Selling Dealership: Round Rock Toyota Vehicle Identification Number (VIN) (Last 4 Digits): [XXX] ________________________________________ I. Overview of Complaint: Critical Safety Defect I am filing this formal complaint directly with Toyota Motor Corporation regarding a vehicle that, due to an apparent critical manufacturing defect, failed dangerously and repeatedly within days of purchase. This failure represents a lapse in Toyota's quality control and a serious threat to consumer safety. The vehicle, purchased new or recently, on [XXX], exhibited critical operational defects less than three days after leaving the dealership. This vehicle is demonstrably defective and unsafe, having compromised my life during a near-fatal failure on a major interstate. As the manufacturer, Toyota is ultimately responsible for the quality and safety of the product delivered to consumers. II. Factual Timeline of Critical Defects and Safety Incidents The vehicle exhibited multiple critical failures less than 77 miles and three days after purchase, severely compromising my safety and confidence in the quality of the Toyota product: •Immediate Operational Failures: The vehicle began experiencing multiple mechanical failures shortly after purchase. •Near-Fatal Highway Stall: The most severe incident involved the vehicle suddenly failing and stalling while traveling on a major interstate. This catastrophic failure is indicative of a serious underlying manufacturing or component defect and severely endangered my life and the lives of others. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Dec 05, 2025

Injuries: 1

STEERING

1 complaint

2025 RAV4 - While driving the car, changing from reverse to drive the steering wheel got stuck and would not go back to straight position. This causes an accident and hit another car. There was not indicator that there is a problem. Inspection was done by the dealership and asap and they identified and confirmed of faulty steering wheel angle. This car was bought end of June and accident happened first week of October. The car is since with the dealership with no resolution yet. Dealership have us call Toyota, but we were not provided with any help. One and half month in, we continue to pay insurance but we do not have the car.

Nov 17, 2025

Crash: 1

STEERING,ELECTRICAL SYSTEM,ENGINE

1 complaint

While waiting in a drive-thru with “hold” feature enabled, car vibrated abnormally and shut off by itself. When I attempted to restart the vehicle, I received an error message “Engine Stopped. Steering Power Low” and another screen also appeared that said, “Not Ready to Drive. Press Brake and Push Engine Start Switch.” I followed those instructions several times and the car wouldn’t start. Eventually had to put in neutral to get out of drive-thru. Once out of drive-thru, I once again attempted to restart the car, but this time it worked. Should mention it was raining pretty heavily outside when this happened.

Nov 15, 2025

BACK OVER PREVENTION

1 complaint

While reversing vehicle screen went blank once and another time flickering on screen, felt safety issue reversing.

Nov 14, 2025

EXTERIOR LIGHTING

1 complaint

Back up camera delay in lighting up when car is started

Sep 13, 2025

AIR BAGS,FORWARD COLLISION AVOIDANCE

1 complaint

On 9/5, a car darted out in front of me while I was traveling straight at 45 miles per hour. I hit the brakes but t-boned him. The car then spins around and hits me again on the passenger quarter panel. No emergency brake, precollision no warning light came on. The airbag didnt deploy. I hit my chest on the steering while and my head on the window. The seat belt didnt lock me down. I purchased the brand new Rav4 a week prior.

Sep 09, 2025

Crash: 1

Injuries: 2

STRUCTURE,UNKNOWN OR OTHER

1 complaint

Enter water when open doors after to rain. All the doors. Dealer in Puerto Rico not resolver problem.

May 24, 2025

ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

Check engine light came on as well as hybrid malfunction message. While on the highway could not accel or go past 60 mph, gas pedal would then not work and speed went down, I pulled car over to breakdown lane and car abruptly stopped and would not move. Many warnings flashed and car needed to be towed. Temperature rose and ignition messages came up, steering wheel locked and car was not drivable.

May 17, 2025

VISIBILITY

1 complaint

The contact owns a 2025 Toyota Rav4. The contact was experiencing dizziness, nausea, and lack of focus in vision while in the driver's seat and looking through the windshield. The contact took the vehicle to the dealer who sat in the driver’s seat and noticed the glass was magnified in certain areas causing visual distortion and warping in certain areas of the windshield. The windshield was replaced. The contact experienced the same physical reaction to the new windshield. The dealer was contacted, and a message was left. The contact learned that the manufacturer had outsourced the manufacturing of the windshields from a company called AGC. The windshield was not replaced a second time. The manufacturer was not informed of the failure. The failure mileage was approximately 495.

Apr 28, 2025

POWER TRAIN,VEHICLE SPEED CONTROL

1 complaint

I have owned this new vehicle for only approximately 2 months and have had at least 4 instances where the vehicle does not respond immediately to my foot on the accelerator when attempting to restart from a stop. Three times I was at a stop light and when I attempted to go as the light turned green there was no acceleration response from the gas pedal for a couple of seconds, and in two of the instances because I had my foot pressed far on the gas attempting to get power, there was a sudden acceleration and lurch forward. Most recently, on the fourth occasion I was turning out into traffic from a parking lot after being at a standstill and got no response and instead rolled slowly out in front of an oncoming car until after a few seconds the accelerator finally responded and I could go. I believe this is a safety risk as it could happen when I was attempting a left turn in traffic, which would subject me and my passengers/children to an extreme risk of being hit. I took the car into the dealership after the first two instances and they were not able to reproduce the incidents and offered no help. There are no warning lamps or indicators that appear when this occurs. The first incident occurred about three weeks into my ownership of the vehicle.

Apr 24, 2025

POWER TRAIN

1 complaint

When remote starting the vehicle. The vehicle allows you to put the vehicle in gear from inside and turn off the parking brake allowing the vehicle to roll freely. The vehicle does shut off 1-2 seconds after but the vehicle is already in gear. To reproduce the defect you must remote start the vehicle using either the Toyota app or smart key fob. You then must be sitting in the vehicle once the vehicle is started you quickly depress the brake pedal shift into gear and turn off the parking brake quickly. The vehicle then shuts off while in gear allowing the vehicle to roll freely. This increases the risk of accident as the driver may not be in the vehicle and a child or other person may accidentally put the vehicle in gear while remote started. I believe this issue affects many other Toyota and Lexus vehicles as many share the same platforms and systems. You may contact me at my email address listed for more information or a video recording of the defect. Thanks.

Feb 23, 2025

⭐

4.4/5.0

95 reviews

Frequently Asked Questions

How many problems does the 2025 TOYOTA RAV4 have?

The 2025 TOYOTA RAV4 currently has 30 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2025 TOYOTA RAV4?

The most common problems reported for the 2025 TOYOTA RAV4 are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2025 TOYOTA RAV4 problem data come from?

All problem and complaint data for the 2025 TOYOTA RAV4 comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.