2005 TOYOTA Tundra Problems & Complaints
Real owner complaints and problems reported to the National Highway Traffic Safety Administration (NHTSA). View common issues by component.
VIN Decoder
374
Complaints Reported
As an Amazon Associate, ForCar.org earns from qualifying purchases.
Complaints by Component
AIR BAGS
79 complaints
Takata Recall. The contact owns a 2005 Toyota Tundra. The contact had notification of NHTSA Campaign Number: 19V741000 (Air Bags) however, the contact was unable to take the vehicle to a local dealer for the recall repair. The contact made a local dealer aware of the issue and was informed that they were unable to provide a field technician or towing assistance and the contact was referred to the manufacturer for assistance. The vehicle was not repaired. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Apr 06, 2023
The contact owns a 2005 Toyota Tundra. The contact stated that while his son was driving at an undisclosed speed, the driver’s side air bag was inadvertently deployed without warning. There was no impact to the vehicle to cause the driver’s side air bag to deploy. The vehicle was taken to the dealer where the manufacturer sent a field technician to inspect the vehicle. The contact was not made aware of the diagnosis. The manufacturer was made aware of the failure and informed the contact that the hot weather conditions caused the air bag to deploy. The failure mileage was approximately 64,000.
May 19, 2022
The contact owns a 2005 Toyota Tundra. The contact stated his wife was driving on the highway at approximately 40 MPH when she hit a patch of ice and spun out of control crashing into an embankment on the rear driver side. As a result, the rear driver side tire was pushed back out of place about an inch and a half causing the control arm to become bent. The air bags did not deploy. The wife was not injured. A police report was filed. The vehicle was able to be driven from the scene. The vehicle was not diagnosed or repaired. A dealer was not contacted. The vehicle was currently being repaired at a body shop for cosmetic repairs. The manufacturer was not notified of the failure. The failure mileage was 215,000
Mar 25, 2022
MANUFACTURER AND DEALERSHIP IS NOT RESPONSIVE IN TRYING TO REMEDY THE AIR BAG ISSUE. I'M RECEIVING MULTIPLE REMINDERS TO GET MY VEHICLE FIXED FOR THE TAKATA AIR BAG RECALLS. I HAVE 2 OUTSTANDING ISSUES. I CALLED AUTONATION TOYOTA IN HAYWARD, CA. THEY SAID THEY'D CALL ME BACK AS THEY HAD TO ORDER THE PARTS. ALMOST 2 MONTHS LATER, I CALLED TO FOLLOW-UP AS THEY NEVER CALLED ME BACK. THEY THEN TOLD ME THAT IT SHOWS IN THEIR RECORDS THAT THEY SERVICED MY VEHICLE AND REMEDIED THE ISSUE. IF YOU LOOK AT THE ONLINE RECORDS, IT SHOWS THAT THE 2 RECALLS ARE STILL UNREMEDIED. ALSO, I WOULD KNOW IF I BROUGHT MY VEHICLE IN FOR THE REPAIR. I TALKED TO A PERSON NAMED JULIAN AT THE DEALERSHIP.
Nov 20, 2020
TL* TAKATA RECALL. THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V741000 (AIR BAGS). THE CONTACT STATED THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CALLED STREET TOYOTA (4500 S. SONCY RD, AMARILLO, TX 79119, (806)355-9846 WHO STATED THAT PARTS WERE NOT YET AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. PARTS DISTRIBUTION DISCONNECT.
Sep 03, 2020
+ 74 more complaints for this component
STRUCTURE
60 complaints
The frame is so rusted in my truck my mechanic said it may snap at anytime and is not safe to drive. I know Toyota tundra’s from 2000-2003 have been recalled for same reason.
Dec 09, 2025
1)Frame is rusting out. Not repairable. 2) Fuel tank strap rusted through and broken.
Jun 12, 2025
know issue with Toyota Tundra Frame, and refuse to give option to repair.
Aug 22, 2024
We are the first owner of this 2005 Toyota Tundra Limited with only 91K miles. The frame is rusted so badly that we are afraid to drive down the road. This rusted problem could cause potential harm or death to us and others on the road.
Jun 28, 2024
The contact owns a 2005 Toyota Tundra. The contact stated that the sub frame was rusted and had holes. The parking brake and oil warning lights were illuminated. The vehicle was taken to the local dealer, who determined that the vehicle might not pass a safety inspection due to the position of the holes and rust. The warning lights were repaired but the sub frame was not repaired. The vehicle was taken to a frame shop, the frame shop declined to service the vehicle. The manufacturer was contacted and informed the contact about an Extended Warranty, but no assistance was provided. The failure mileage was approximately 139,000.
Jun 12, 2024
+ 55 more complaints for this component
SUSPENSION
40 complaints
The contact owns a 2005 Toyota Tundra. The contact stated that while driving at 35 MPH, the driver’s side front ball joint detached causing the front driver’s side wheel to bend inward. No warning lights were illuminated. The vehicle was towed back to the residence which caused damage to the fender. The dealer was made aware of the failure and informed the contact that the vehicle was previously repaired under NHTSA Campaign Number: 07V013000 (Suspension) however, the failure occurred. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 290,000.
Apr 24, 2024
Toyota did an inspection for frame rust years ago, but mine is now rusting out I believe it should have been swapped at the time of the recall.
Jan 16, 2023
i recently purchased the 2005 Tundra I was instructed to take the Tundra to Westbury Toyota for inspection and they didnt even took at the truck they claimed according to the VIN is not eligible for any consideration from Toyota North North America The frame has recessive deterioration. We understand the truck doesnt have lifetime warranty but I am disappointed in Toyota's response
Nov 09, 2022
Front left wheel fell off. What component or system failed or malfunctioned, and is it available for inspection upon request? FRONT LEFT WHEEL. YES, AVAILABLE FOR INSPECTION How was your safety or the safety of others put at risk? WHEEL FELL OFF Has the problem been reproduced or confirmed by a dealer or independent service center? YES. TOWED TO SHOP; THEY AGREED THAT FRONT LEFT WHEEL FELL OFF. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? CAPITOL BODY SHOP, RIDGELAND, MS Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? UKNOWN. VEHICLE HAS MADE NOISE OFF AND ON, BUT WHETHER DUE TO THIS I CANNOT SAY. PLEASE NOTE: THIS VEHICLE WAS SUBJECT TO Recall Number 07V013000 Recall Date 01/19/2007 lOWER BALL JOINT. THIS VEHICLE HAD THAT SERVICE DONE IN LAS VEGAS NEVADA AT APPROX 12,500 MILES. WHAT FAILED WAS THE FIXED/REPAIRED/REPLACED JOINT. ALL
Apr 19, 2022
I believe my Toyota frame is rusted. The truck has 56,000 miles. The front wheel has a noticeable problem with the camber - it can not be driven safely.
Mar 14, 2022
+ 35 more complaints for this component
POWER TRAIN
20 complaints
2005 TUNDRA WITH MANUAL TRANSMISSION HAS ISSUE WITH 3RD GEAR GRINDING AND POPPING OUT OF GEAR WHEN DRIVING CAN SEE MANY COMPLAINTS ONLINE WITH TUNDRA AND TACOMA WITH 6 SPEED MANUAL TRANSMISSIONS AND SOME INDICATIONS TOYOTA NEW THE ISSUE WAS BAD SYNCHROS IN TRANSMISSION AND CHANGED TRANSMISSIONS OUT WITH ONES CONTAINING HEAVY-DUTY SYNCHROS WHEN THEY WERE FAILING WITH 18000 MILES, OTHERWISE ONCE OUT OF WARRANTY YOUR PROBLEM. SOME PEPOLE STATED REPLACEMENT DONE MORE THAN ONCE. POPS OUT OF GEAR WHILE DRIVING ON STREET
Nov 10, 2017
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED AND THE IGNITION WAS TURNED TO THE ON POSITION, THE VEHICLE MOVED WITHOUT BEING PROMPTED. THE CONTACT JUMPED INTO THE VEHICLE AND ATTEMPTED TO STOP THE VEHICLE BUT THE VEHICLE CRASHED INTO A HOUSE. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT SUSTAINED INJURIES TO HER LEFT LEG THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS UNKNOWN.
Jan 11, 2016
THE DIFFERENTIAL HOUSING RUSTED THROUGH SO THAT THE LUBRICATING FLUID LEAKED OUT ONTO THE ROAD. THIS HAPPENED BOTH WHEN THE TRUCK WAS MOVING AND AT REST. TOYOTA HAD ALREADY REPLACED THE VEHICLE FRAME AS RAPID CORROSION AND RUSTING CAUSED A RECALL. THE DIFFERENTIAL TRANSFERS POWER TO THE REAR WHEELS SO THE LACK OF LUBRICATION COULD HAVE CAUSED THE REAR WHEELS TO LOCK WHILE DRIVING WITH THE POTENTIAL FOR A REAR END COLLISION OR COMPLETE LOSS OF CONTROL AT HIGH SPEED. USED REPLACEMENT DIFFERENTIAL HOUSINGS ARE UNAVAILABLE BECAUSE OF HIGH DEMAND DUE TO FAILURE OF ORIGINALS DUE TO RUST.
Nov 23, 2015
AFTER STOPPING AT A RED LIGHT. MADE RIGHT TURN UPHILL. TRUCK ACCELERATED QUICKLY LIKE IT WAS FLOORED. ATTEMPTED TO BRAKE EASILY TO SLOW DOWN. TRUCK SPUN 180 ON PAVEMENT, CRASHING SIDEWAYS INTO ISLAND DIVIDER. RIGHT REAR WHEEL WAS SHEERED OFF. TRUCK WAS STOPPED BY REAR BUMPER SMASHING INTO LIGHT STANDARD. SHEERED WHEEL HAD GRIND MARKS AS WHEELS WERE STILL UNDER POWER. THIS WAS POINTED OUT AT SCENE BY LAW ENFORCEMENT. I AM A RETIRED FIREFIGHTER USED TO DRIVING EMERGENCY EQUIPMENT. MY TRUCK ACCELERATED ON ITS OWN. *TR
Jan 23, 2012
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED THE CHECK ENGINE LIGHT ILLUMINATED AND THE VEHICLE WOULD BECOME RESISTANT WHEN DRIVING UPHILL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE A DIAGNOSTIC TEST SHOWED A FAULTY TRANSMISSION SOLENOID. THE DEALER STATED THAT THE ENTIRE TRANSMISSION WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 91,000.
May 26, 2011
+ 15 more complaints for this component
UNKNOWN OR OTHER
11 complaints
I purchased a 2005 Toyota Tundra for my son for his first vehicle. After taking it to a professional mechanic to be inspected I was told that the frame is rotted from rust and cannot pass inspection. After researching this issue i found that toyota had a recall on their frames because of how many and how bad the frames were. I believe this tundra rates the recall because of how bad the rust is. Any help getting this recall to fix this known issue with the rusting frames would be greatly appreciated, thank you for your time.
May 24, 2024
The frame on this truck is severely compromised by rust. This is a well known problem with early Toyota Tundras, and Toyota issued a recall that ended with model year 2004, despite knowing that it was also an issue with 2005 and 2006 models as well. This is one of these trucks. This particular truck has large rust holes in the frame near the front driver's side wheel, and had multiple very weak spots that are on the brink of failure, all while the body and suspension components are in relatively good shape still. This creates a significant safety hazard. A Toyota dealership in Effingham, IL looked at the frame a number of years ago, but didn't do any work on it, claiming that it was not covered by Toyota's recalls or service bulletins.
Apr 27, 2024
Was told my truck would not be able to be inspected next year because of a rotting FRAME! This potentuly means I will not have a safe vehicle. I have not brought my truck to a dealer...but I must say I did have the same problem with my last truck a (Toyota Tundra) and it was taken care of and was PLEASED by the outcome, that is why I bought another of the same. I feel after spending the money a vehicle costs this is something the manufacture should remedy. With the cost of a new vehicle..it is almost impossible to buy. My truck is in good running condition along with being a great truck. If it weren't for the rotting frame I'm sure I would get many more years of service from it. Any help in this matter would be appreciated. Thank you , [XXX] [XXX] PS If pictures are needed I will supply them, just ask. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Apr 19, 2024
The frames of Toyota trucks are known for rusting through and perforating causing the vehicle to be unsafe to own/drive. My frame is seperating and rusting through. The dealer "stated" they performed a treatment to prevent this deterioration from happening, however it clearly did not work. I have contacted the dealer to have the frame replaced under the safety recall but the are refusing since they said it was already attempted to be "treated". The vehicle is in excellent working condition and Toyota should honor this safety recall since it was a manufacturing issue that is causing these frames to fail prematurely. I do not feel safe driving my truck in the condition it is in but cannot afford to buy another since Toyota will not replace the failed frame.
Jan 21, 2024
The frame is rusted, luckily a mechanic caught it in time, it’s not road worthy.
Sep 19, 2022
+ 6 more complaints for this component
VEHICLE SPEED CONTROL
11 complaints
UNCONTROLLABLE ACCELERATION: MY HUSBAND'S 2005 TOYOTA TUNDRA ACCELERATED AT A VERY HIGH SPEED WHILE HE HAD HIS FOOT ON THE BRAKE AT A STOP SIGN. HE HAD HIS BACK PUSHED UP AGAINST THE SEAT AND PUSHED AS HARD AS HE COULD ON THE BRAKE, BUT THE TRUCK TOOK OFF ANYWAYS AND HE WAS FORCED TO PULL OUT IN FRONT OF ONCOMING TRAFFIC. LUCKILY HE WASN'T HIT. THIS IS THE SECOND TIME THIS HAS HAPPENED IN THIS TRUCK. IN JANUARY OF 2015 HE WAS BACKING INTO OUR DRIVEWAY WHEN HIS TRUCK SUDDENLY ACCELERATED AT A VERY HIGH SPEED. HE PUT HIS FOOT ON THE BRAKE AND THE TIRES KEPT SPINNING. HE PUT THE TRANSMISSION INTO PARK AND AFTER A FEW MORE SECONDS THE TIRES STOPPED SPINNING. WE CONTACTED TOYOTA AFTER BOTH OCCURRENCES, BUT THEY WON'T HELP US AT ALL. THEY SAY THAT THE TRUCK ISN'T INCLUDED IN THE RECALL AND THAT IT'S NO LONGER UNDER WARRANTY.
Jul 14, 2016
MY VEHICLE SUDDENLY LOST POWER BECAUSE THE PLASTIC FAN IN THE SECONDARY INJECTION SYSTEM BROKE AND THE PIECES BLEW INTO THE EXHAUST PORTS AND MELT, STICKING UP THE EXHAUST PORTS. THE VEHICLE DOESN'T RUN RIGHT AND IS A SAFETY HAZARD BECAUSE OF A DESIGN PROBLEM. TOYOTA ACCEPTS THE PROBLEM AND HAS EXTENDED THE VEHICLE WARRANTIES FOR THE 2007-2010 MODEL YEARS, BUT NOT FOR MY MODEL YEAR. REPAIR HAS COST ME OVER $3,000 FOR THEIR MISTAKE. IT IS A SAFETY HAZARD. IT SHOULD BE RECALLED.
Dec 08, 2015
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT WAS DRIVING 45 MPH WHEN THE VEHICLE FAILED TO INCREASE SPEED AFTER THE ACCELERATOR PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE DEALER CONFIRMED THAT THE PUMP ASSEMBLY AIR SWITCH NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED BUT THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 57,500 AND THE CURRENT MILEAGE WAS 57,700.
Mar 28, 2012
I DRIVE A 2005 TOYOTA TUNDRA THAT HAS ACCELERATED ABOUT A DOZEN TIMES SINCE I BOUGHT IT. SEEMS THAT WHEN I HIT A MAJOR BUMP THAT'S RISING ACROSS THE LANE I'M IN AND GO ACROSS IT, MY TRUCK WILL ACCELERATE MOMENTARILY WITHOUT ME PRESSING ON THE GAS PEDAL. I CANNOT ALWAYS DUPLICATE THIS ACTION AND WHEN I GO TO THE DEALER IT COMES BACK AS PROBLEM NOT FOUND. AS I MENTIONED IT'S ONLY OCCURRED MAYBE A DOZEN TIMES SINCE 2005 BUT IT IS A CONCERN AFTER ALL THE RECALLS THAT TOYOTA HAS HAD. I RECENTLY COMPLETED 95,000 MILES ON MY VEHICLE AND HAVE BEEN HAPPY WITH IT'S PERFORMANCE WITH THIS EXCEPTION. *TR
Jul 19, 2010
2005 TOYOTA TUNDRA, UNINTENDED ACCELERATION, MY HUSBAND WAS PUTTING IT IN THE DRIVEWAY AND IT ACCELERATED INTO THE NEIGHBORS FENCE AND DROVE OVER A FOUR WHEELER IF HE HADN'T PUT IT INTO PARK HE WOULD HAVE CONTINUED INTO THE NEIGHBORS HOUSE. THE ACCELERATION PROBLEMS HAVE HAPPENED QUITE A FEW MORE TIMES THOUGH NOT TO THIS EXTENT, TOYOTA IS REFUSING TO FIX OR EVEN TAKE A LOOK AT THE TRUCK, SAYING IT ISN'T ON THE RECALL LIST SO IT ISN'T THEIR FAULT. THE TOYOTA PROBLEM IS BIGGER THAN THEY ARE ADMITTING TO AND SOME INVESTIGATING IS NECESSARY, THIS TRUCK IS A DANGER AND THEY ARE RESPONSIBLE. *TR
Feb 28, 2010
+ 6 more complaints for this component
ENGINE AND ENGINE COOLING
10 complaints
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. WHEN THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE FAILED TO RESPOND. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE AIR INJECTOR PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.
Dec 31, 2015
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. IMMEDIATELY AFTER STARTING THE VEHICLE, AIR BEGAN LEAKING FROM THE AIR INJECTION SYSTEM AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE FAILURE OCCURRED MULTIPLE TIMES. AN INDEPENDENT MECHANIC STATED THAT THE AIR INJECTION SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 126,000.
Aug 19, 2014
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. WHILE DRIVING 35 MPH, THE EMISSION CONTROL FAILED AND THE WARNING INDICATOR ILLUMINATED. THE FAILURE OCCURRED TWICE. AN INDEPENDENT MECHANIC RECOMMENDED THAT THE SECOND AIR INJECTION SYSTEM BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.
Aug 07, 2014
2005 TOYOTA TUNDRA. CONSUMER WRITES IN REGARDS TO AIR INDUCTION PUMP DESIGN FLAWS *TGW THE CONSUMER STATED ACCORDING TO THE MECHANIC'S REPORT, THE SECOND AIR PUMP, SECONDARY AIR SWITCHING VALVE, BANK 1 AND BANK WERE REPLACED. THEY WERE ALL CLOGGED WITH INSULATION FOAM AND STUCK TO THE VALVE SEATS WHICH KEPT THE VALVES OPEN. THE SECONDARY AIR INLET WAS ALSO REPLACED, DUE TO THE HOSE BEING HARD BECAUSE OF THE HEAT UNDER THE INTAKE MANIFOLD, WHICH ALSO CONTRIBUTED TO THE ENGINE NOT BEING ABLE TO COOL PROPERLY. FURTHER RESEARCH ABOUT AIR INDUCTION PUMP DESIGN FLAWS ON TOYOTA VEHICLE REVEALED A NATIONWIDE PROBLEM AFFECTING TUNDRA'S UP UNTIL THE 2010 MODEL.
Aug 15, 2012
MY 2005 TOYOTA TUNDRA HAS A LEAKING EXHAUST MANIFOLD. ON THE WAY HOME FROM THE HARDWARE STORE MY NEW CO DETECTOR WENT OFF INDICATING CO IN THE CABIN. I HAVE CONTACTED THE DEALER AND THE MANUFACTURER AND THEY REFUSE TO REPAIR. *KB
Jul 21, 2011
+ 5 more complaints for this component
SERVICE BRAKES, HYDRAULIC
10 complaints
MALFUNCTIONING BRAKE SENSORS ON 2005 TUNDRA USES ABS TO OVERRIDE DRIVER'S BRAKING BELOW 10 MPH. THE DEFECT IS THAT "ABS" LIGHT DOES NOT APPEAR ON DASH TO INFORM THE DRIVER THAT HE DOES NOT HAVE FULL BRAKING AUTHORITY OVER THE VEHICLE WHEN THE ABS KICKS IN. THE TOYOTA DEALER HAD DAMAGED THE BRAKE SENSOR WHILE REPLACING THE REAR AXLE BEARINGS. I DROVE THE SERVICE MANAGER TO WITNESS THE LOSS OF BRAKING CONTROL. THE BRAKE SENSOR WAS REPLACED AND PROBLEMS SOLVED. BACK TO THE PROBLEM. I OVER SHOT A STOP LINE BY A FEW FEET IN HEAVY TRAFFIC. LUCKILY, I WAS THE FIRST ONE AT THE RED TRAFFIC LIGHT. IT SOUNDED LIKE THE ABS KICKED IN, BUT ABS LIGHT DID NOT ILLUMINATE. I THOUGHT THE BRAKING SYSTEM WAS RECALIBRATING ITSELF (WHO KNOWS HOW ALL THESE ONBOARD COMPUTERS OPERATE THESE DAYS), BUT THE ABS WAS KICKING IN. *TR
Aug 13, 2010
TL*THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT WAS DRIVING AT APPROXIMATELY 35 MPH WHEN ANOTHER VEHICLE MOVED INTO HER LANE. TO AVOID AN ACCIDENT, SHE DEPRESSED THE BRAKE PEDAL BUT THE VEHICLE WAS UNRESPONSIVE AND DID NOT SLOW DOWN. AS A RESULT, THE VEHICLE CRASHED INTO THE OTHER VEHICLE. THERE WERE TWO PEOPLE INJURED. THE POLICE WERE CALLED TO THE SCENE OF THE ACCIDENT AND A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE INSURANCE COMPANYS AUTOMOTIVE BODY SHOP FOR INSPECTION WHERE IT WAS DETERMINED THE VEHICLE WAS TOTALLED. THE CURRENT AND FAILURE MILEAGES WERE 74,645.
Mar 26, 2010
TOYOTA TUNDRA 2005 - WHEN BRAKING THE FRONT END SHUDDERS AND MOVES BACK AND FORTH. WHEN FRONT BRAKING SYSTEM WAS INSPECTED THE ROTORS HAD WARPED. TOYOTA ISSUED A 2005 REPAIR NOTIFICATION THAT BRAKE ROTORS WERE WARPING BUT DID NOT POSE A SAFETY PROBLEM. TOYOTA RECOMMENDED REPAIRS REQUIRE REPLACEMENT OF THE ROTORS, CALIPERS, AND BRAKE PADS. THERE IS NO GUARANTEE THAT THIS WILL RESOLVE THE PROBLEM PER THE REPAIR NOTIFICATION. MY VEHICLE CONTINUES TO SHUDDER WHEN APPLYING THE BRAKES WITH POTENTIAL LOSS OF CONTROL AT HIGHWAY SPEEDS. I HAVE NOT HAD THE RECOMMENDED REPAIRS DONE SINCE THE ESTIMATED COST IS $2200 PER MY LOCAL TOYOTA DEALER. *TR
Mar 16, 2010
WHILE DRIVING MY 2005 TOYOTA TUNDRA, THE CAR IN FRONT OF ME STOPPED SUDDENLY. I HIT MY BRAKES HARD BUT FELT THE CAR GO ALONG AS IF IT WAS IN NEUTRAL, NO BRAKING AT ALL. I CRASHED INTO THE CAR IN FRONT OF ME CAUSING SIGNIFICANT DAMAGE. *TR
Feb 25, 2010
EVERYTIME I CAME TO A STOP LIGHT OR SIGN, THE BRAKES WOULD LOSE PRESSURE AND THEN THE CAR STARTS GOING THROUGH THE LIGHT, WHILE I AM STILL HOLDING THE BRAKES. THE WOULD ALSO LOSE PRESSURE TO WHERE I COULD NOT STOP IN THE MIDDLE OF A HOT DAY. PROBLEM WAS CONSISTENT FIRST THING IN THE MORNING ON THE WAY TO WORK. TOOK IT TO TOYOTA DEALER AND THEY COULD NOT FIGURE IT OUT AT FIRST. THEY HAD ME REPLACE THE BRAKE PADS, AND ROTORS AND BLEED THE LINES NUMEROUS TIMES. THIS STILL DID NOT WORK AND THEY SAID I NEEDED A NEW MASTER CYLINDER/BRAKE BOOSTER. THIS ASSEMBLY IS ALL IN ONE SO THE WHOLE UNIT HAD TO BE REPLACED COSTING OVER $2,000 FOR THE PARTS NOT INCLUDING LABOR. THE TRUCK IS A 2005 TOYOTA TUNDRA WITH ONLY 60,500. THEY TOLD ME I WAS OUT OF WARRANTY AND HAD TO PAY THE COST BECAUSE THEY HAVE NEVER HEARD OF THIS FAILURE BEFORE. *TR
Oct 14, 2008
+ 5 more complaints for this component
SUSPENSION,STRUCTURE
9 complaints
This report addresses the critical structural integrity concerns related to excessive corrosion, and frame material loss affecting the main ladder frame chassis. The degradation of the frame members poses a significant and immediate safety risk, including potential catastrophic structural failure, detachment of critical components, and failure of safety systems (e.g., braking and fuel lines) mounted to the frame. Location: Mid-frame section (beneath the cab) and rear sections (near the leaf spring mounts and rear axle).
Oct 29, 2025
Frame rusted thru to point it is unsafe to drive
Feb 16, 2024
******* DELETE VOQ ******* THIS COMPLAINT IS BEING MARKED FOR DELETION BECAUSE THE CONSUMER PLACED THE REQUEST.*DJR ******* DELETE VOQ *******
Nov 10, 2022
LIMITED SERVICE CAMPAIGN DSD 2004-11006 TUNDRA FRAME INSPECTION. I BOUGHT AN 05 TUNDRA LAST YEAR. CALLED TOYOTA AND THEY SAID THIS RECALL IS OVER. MY FRAME NEEDS REPAIRING. THEY ARE NOT HELPING. DO I HAVE ANY RECOURSE?
Mar 16, 2021
SIGNIFICANT FRAME CORROSION IN MULTIPLE AREAS TO INCLUDE ONE AREA WITH A HOLE ALL THE WAY THROUGH THE FRAME RAIL, AND MOST ACUTELY WHERE THE REAR LEAF SPRING CONNECTS TO THE FRAME WITH ONLY 50% OF THE CONTACT AREA APPEARING TO BE STRUCTURALLY SOUND. INSPECTED BY TOYOTA DEALERSHIP WHO RATED DAMAGE AS JUST BARELY BETTER THAN UNSAFE TO DRIVE, HOWEVER NOT COVERED UNDER RECALL. VEHICLE HAS 175K MILES ON IT, AND HAS SPENT THE MAJORITY OF ITS LIFE IN SC AND MD WHERE ROAD SALT USAGE IS LOW. FREQUENTLY CLEANED UNDERCARRIAGE, AND PERIODIC APPLICATION OF CORROSION PREVENTATIVE COMPOUNDS DID NOT ALTER OUTCOME WHICH IMPLIES POOR MATERIALS AND/OR MANUFACTURING DEFECTS. *TR
Apr 08, 2020
+ 4 more complaints for this component
SERVICE BRAKES
8 complaints
The contact owns a 2005 Toyota Tundra. The contact stated while driving 40 MPH and depressing the brake pedal, the vehicle failed to stop and crashed into the vehicle ahead. The contact stated no warning light was illuminated. The contact stated that the air bags did deploy. The contact sustained injuries to his back, neck, right shoulder, and right clavicle. The other driver sustained injuries to his back and neck. The contact sought medical attention from a physical therapist but was unaware if the other driver sought medical attention. A police report was filed. The contact was able to park on the side of the road but then towed the vehicle to his residence. The vehicle was not diagnosed nor repaired. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was 266,313.
Jan 27, 2023
THE PARK BRAKE SYSTEM USES CABLES TO EXPAND THE REAR BRAKE SHOES. THE SHOES ARE EXPANDED USING A BELLCRANK AND BRACKET. WHEN THE PARK BRAKE PEDAL IS DEPRESSED, THE CABLE PULLS THE BELLCRANK AND EXPANDS THE SHOES. THE BELLCRANK AND BRACKET USE A PIVOT PIN. THE ENTIRE ASSEMBLY - BELLCRANK, BRACKET AND PIN SUFFER EXTRAORDINARY RUST. THE RUST CAUSES THE PARK BRAKE TO FAIL TO RELEASE. THE REAR BRAKES DRAG, AND CAUSE: * PREMATURE WEAR OF REAR BRAKES * LOSS OF FUEL ECONOMY * SHUTTER AND SHAKING FROM THE REAR * AVOIDING USE OF PARK BRAKE SYSTEM TO AVOID THE PROBLEM, FOLKS DON'T USE THE PARK BRAKE. NONE OF THE DRIVERS OF OUR TOYOTA TUNDRA USES THE PARK BRAKE BECAUSE OF THE THE PROBLEMS IT CAUSES. THAT'S A SAFETY ISSUE. APPARENTLY THIS IS A WELL KNOWN PROBLEM WITH TOYOTA TUNDRAS. ALSO SEE HTTPS://WWW.TUNDRASOLUTIONS.COM/THREADS/PARKING-BRAKE-STICKING.30818/ . OUR PROBLEM HAS BEEN HAPPENING FOR YEARS. WE HAVE NOT USED THE PARK BRAKE IN OVER A DECADE. WE ARE REPORTING THE ISSUE NOW BECAUSE WE RECENTLY LEARNED HOW EASY IT IS TO REPORT THE ISSUE USING THE NHTSA.GOV WEBSITE.
Oct 07, 2020
THE LAST 3 VEHICLES I'VE OWNED HAVE HAD TOTAL BRAKE FAILURE DUE TO BRAKE LINE FAILURE/ WITH VEHICLES LASTING LONGER AND SALT TREATING FOR WINTER PRECIPITATION, STAINLESS SHOULD BE REQUIRED. THE MOST RECENT WAS A TOYOTA TUNDRA. PREVIOUSLY AN EXPEDITION AND A LEXUS RX300
Jun 22, 2019
TL* THE CONTACT OWNS 2005 TOYOTA TUNDRA. THE CONTACT STATED WHILE DRIVING 30 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT FAILED TO STOP THE VEHICLE AS THE BRAKE BARRIER WARNING INDICATOR ILLUMINATED. THE CONTACT STATED THAT HE DRIVE UPHILL AND WHEN THE VEHICLES STARTED ROLLING BACKWARDS, HE DEPRESSED THE BRAKE PEDAL AND THE VEHICLE STOPPED. THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 175,000.
Oct 29, 2018
GOT IN TRUCK, STARTED IT, BRAKE LIGHT REMAINED ON. WHILE DRIVING, BRAKES WERE SOFT. CHECKED BRAKE FLUID RESERVOIR, LOW ON FLUID. ADDED BRAKE FLUID, PUMPED BRAKES- PEDAL WENT TO THE FLOOR. FLUID UNDER RIGHT FRONT WHEEL. HAD TRUCK TAKEN TO MY MECHANIC - BRAKE LINE RUSTED OUT, ALL ALL OTHER LINES RUSTED AS WELL. RECOMMENDED ALL GET REPLACED AS A SAFETY ISSUE. NOT ONLY RUST ISSUES WITH THIS VEHICLE- WAS IN THE TOYOTA CHASSIS RECALL- CHASSIS COATED WITH RUST INHIBITOR. DIFFERENTIAL RUSTED OUT- REPLACED AT MY COST. TOYOTA TOOK NO RESPONSIBILITY. ALSO REPLACED THE HOOD RELEASE CABLE, EMERGENCY BRAKE CABLE, AS WELL AS THE TWO CABLES SUPPORTING THE TAILGATE- ALL RUSTED OUT. REAR BUMPER RUSTED OUT TOO.
Apr 03, 2018
+ 3 more complaints for this component
TIRES
8 complaints
275/45R20 SUMITOMO HTR SPORT H/P 110H THIS TIRE BLOWOUT AT ABOUT 45 MILES PER HOUR
Jun 29, 2019
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA EQUIPPED WITH COOPER DISCOVERER S/T MAXX TIRES, SIZE: 265/75/16. WHILE DRIVING 65 MPH, THE REAR PASSENGER SIDE TIRE DEFLATED. THE VEHICLE WENT SIDEWAYS AND ROLLED OVER. THE DRIVER SUSTAINED INJURIES TO THE NECK AND BACK, WHILE THE PASSENGER SUSTAINED A FRACTURED ROTATOR CUFF THAT REQUIRED MEDICAL ATTENTION. THE CONTACT ALSO STATED THAT A REAR SEAT PASSENGER SUSTAINED MINOR BRUISES, BUT NO MEDICAL ATTENTION WAS RECEIVED. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 130,785. THE TIRE FAILURE MILEAGE WAS NOT AVAILABLE. *TR
Jan 30, 2017
I HAVE MULTI MILE WILD COUNTRY TIRES INSTALLED ON MY TRUCK WHICH ARE ONLY A FEW MONTHS AND A FEW THOUSAND MILES OLD. TWO OF THE TIRES HAVE SIDEWALL SEPARATION CRACKS AND ONE IS LEAKING AIR THROUGH THE CRACK. THEY ARE: SIZE 265/70R16 DOT# U9C2 T93 3213. *TR
Aug 16, 2014
MORNING DRIVE FROM FREDERICKSBURG, VA TO SYRACUSE NY ALONG ROUTE 81N. ROADS ARE EMPTY, DRY, & SUN IS UP. I HAD JUST DECIDED TO STOP AT NEXT EXIT FOR BREAKFAST WHEN MY 2005 TUNDRA PICKUP IS VIOLENTLY JERK TO THE RIGHT. I TRY TO FIGHT IT BACK STRAIGHT WHEN IT SUDDENLY TAKES OF TO THE LEFT, THEN JERKS BACK TO THE RIGHT. I HIT THE GUARD RAIL & THE TRUCK FLIPS OVER. THE NEXT THING I REMEMBER I'M HANGING UPSIDE DOWN & I'M HEARING A STRANGE NOISE. I TURN THE KEYS OFF & THE NOISE STOPS. I THINK I SMELL GAS AND FIGHT MY WAY OUT OF THE SEAT BELT & CRAWL OUT WHAT IS LEFT OF THE PASSENGER SIDE WINDOW SINCE THE DRIVERS SIDE IS BLOCKED. WHEN I GET OUT THERE IS SOMEONE YELLING FROM ROAD. I TELL HIM I'M OK & A TROOPER STOPS. I START COLLECTING SOME SILVER COINS THAT ARE SCATTERED WHEN I HEAR THE TROOPER YELLING AT ME. SOUNDING MAD. HE TELLS ME TO STOP & GO TO GUARD RAIL. AS I TRY TO MAKE IT TO GUARD RAIL LEGS & MUSCLES DON'T WORK RIGHT & STARTS HURTING BAD.AMBULANCES ARRIVE (2) AND THEY ARGUE WITH ME. I TELL THEM I DIDN'T CALL THEM & I DON'T WANT THEM. (NO INSURANCE & DON'T WANT TO SEAT IN AN ER FOR THE NEXT 8 HRS JUST TO BE GIVEN PAIN KILLERS & TOLD TO SEE MY DR ASAP.) TOW TRUCK ARRIVES & TELLS TROOPER HE DOESN'T NEED TRAFFIC CONTROL. TROOPER LEAVES AFTER TRYING TO GET ME TO SAY WHAT CAUSED THE ACCIDENT. I DIDN'T KNOW, SINCE I WAS AWAKE & DRIVING THEN I WAS IN THE MIDDLE OF A NIGHT MARE. TOW TRUCK DRIVER DRAGS MY TRUCK UP TO THE GUARD RAIL & POINTS OUT FRONT PASSENGER TIRE & SAYS "THAT'S WHAT CAUSED THE ACCIDENT. A FRIEND FROM NY PICKS ME UP AT THE TOW YARD & ON THE WAY BACK WE STOP AT THE CRASH SITE. WE SEE WHERE THE RIM STARTS CUTTING A GROOVE IN THE BLACK TOP & SWERVES BACK & FORTH THE ROAD. 3 DAYS LATER I MEET INSURANCE ADJUSTER AT TOW YARD & HE ALSO POINTS AT THE FRONT TIRE & SAYS IT CAUSED THE ACCIDENT. WE NOTICE THE TEAR IN THE TIRE IS IN THE OPPOSITE DIRECTION OF ROTATION, SO I PROBABLY DIDN'T RUN OVER ANYTHING. *TR
Dec 15, 2013
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA WITH MICKEY THOMPSON-DICK CEPEK RADIAL F-C II TIRES, LINE SIZE LT285/75R16. THE CONTACT WAS DRIVING 55 MPH WHEN SHE NOTICED AN UNUSUAL SHIMMY IN THE FRONT-END OF THE VEHICLE. THE CONTACT DISCOVERED THAT THE FRONT DRIVER SIDE TIRE EXHIBITED TREAD SEPARATION. THE CONTACT ATTEMPTED TO TAKE THE VEHICLE TO THE DEALER HOWEVER WHILE IN TRANSIT, THE REAR DRIVER SIDE TIRE ALSO FAILED. THE CONTACT WAS ABLE TO LOCATE A RECALL FOR THE TIRES (NHTSA CAMPAIGN ID NUMBER: 06T003000- TIRES: TREAD/BELT) AND WHEN CONTACTING THE TIRE MANUFACTURER, SHE WAS ADVISED THAT THE RECALL WAS EXPIRED. THE MANUFACTURER OFFERED TO TAKE THE LIABILITY FOR THE TIRE AND OFFERED TO CREDIT HER FOR ANOTHER TIRE PURCHASE. THE VIN AND DOT NUMBER WAS UNAVAILABLE. THE CURRENT AND FAILURE MILEAGE WAS APPROXIMATELY 30,000.
Aug 24, 2010
+ 3 more complaints for this component
ELECTRICAL SYSTEM
8 complaints
SINCE MY VEHICLE HIT ABOUT 50000 (THE DATE BELOW IS AN ESTIMATE) AND IT IS AT 79900 NOW WHEN I PARK AND TURN OFF THE IGNITION AND REMOVE THE KEYS AND ROLL UP THE WINDOWS AND LOCK THE VEHICLE AND LEAVE IT A VAST MAJORITY OF THE TIME THE POWER DRIVERS WINDOW ROLLS ITSELF DOWN AT SOME POINT BETWEEN TWO MINUTES AND MANY HOURS LATER ALLOWING FOR ANYONE TO TAMPER WITH ANY OF THE TRUCKS INTERIOR SAFETY DEVICES AND LEADING TO POSSIBLE THEFT OF THE VEHICLE, ITS PARTS AND CONTENTS. IN ADDITION WHETHER THE WINDOW ROLLS ITSELF DOWN OR NOT THE VEHICLES ALARM WILL SOMETIMES SOUND WHEN THERE IS NOBODY NEAR THE VEHICLE AND AFTER HAVING IT CHECKED OUT BY A LOCAL TOYOTA DEALER WHO HAD NO IDEA WHAT IS CAUSING IT NOR HOW TO FIX IT AND SENT ME AWAY WITH PROBLEM UNRESOLVED I HAVE TO OPEN THE HOOD EVERY TIME I PARK AND MANUALLY UNHOOK THE NEGATIVE LEAD TO THE BATTERY WHICH FURTHER EXPOSES ME TO POTENTIAL INJURY EITHER FROM BATTERY MALFUNCTION OR ENGINE MALFUNCTION DUE TO THE CONSTANT DISABLING AND REENABLING OF POWER TO THE ENTIRE VEHICLE AND TO MY PERSON DUE TO BEING STRUCK BY ANOTHER VEHICLE BY STANDING ON FRONT OF MY TRUCK WITH MY VIEW OF MY SURROUNDINGS BLOCKED BY THE RAISED HOOD AND OTHER DRIVERS VIEW OF ME IN THAT UNEXPECTED LOCATION AS I AM IN LARGE PART BLOCKED FROM VIEW BY THE RAISED HOOD. THIS HAS BEEN WITNESSED BY MY MECHANIC AND HIS EMPLOYEES AS WELL AS FAMILY MEMBERS
Feb 25, 2016
TOYOTA HAS EXTENDED ITS WARRANTY FOR THE AIR INJECTION PUMP AND AIR SWITCHING VALVES ON 2007-2010 TUNDRAS. THE EXTENSION IS FOR 10 YEARS OR 150,000 MILES FROM FIRST USE. I HAVE A 2005 TUNDRA THAT HAS A FAILING AIR INJECTION SYSTEM. I AM WITHIN 10 YEARS OF FIRST USE. THE TRUCK HAS THE SAME AIR INJECTION SYSTEM AS THE TUNDRAS WITHIN THE WARRANTY EXTENSION, BUT TOYOTA REFUSES TO HONOR THE WARRANTY EXTENSION ON MY TRUCK. THIS IS A $4000 FIX AND THE TRUCK IS UNSAFE TO DRIVE IN THE CURRENT STATE. *TR
Dec 15, 2014
I HAD A CHECK ENGINE LIGHT THAT CAME ON WHICH, AFTER CHECKED BY A COMPUTER, WAS DETERMINED TO BE PART NUMBER 1445 (P1445). I RESEARCHED IT OUT AND DISCOVERED THAT THIS IS A COMMON PROBLEM WITH THE TOYOTA TUNDRA 2005 MODELS, YET TOYOTA WOULD NOT COVER THE COST NOR DID THEY CARE UNLESS I WAS WILLING TO PAY FOR IT. P1445 IS FOR THE SECONDARY AIR INJECTION SYSTEM VALVE #2 STUCK CLOSED. IS THERE ANY WAY I CAN BE REIMBURSED BY TOYOTA FOR HAVING TO PAY FOR THE REPLACEMENT OF A PART THAT MANY HAVE HAD THE SAME PROBLEM WITH? THIS IS CLEARLY A FAULTY PART PUT INTO THE 2005 TOYOTA TUNDRAS AND TOYOTA SHOULD BE REQUIRED TO PAY FOR IT'S REPLACEMENT. *TR
Dec 14, 2014
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT INDICATED THAT BURNING WIRES FUMES EMITTED FROM THE FRONT OF THE VEHICLE. THE CONTACT STATED THAT THE FAILURE HAD OCCURRED BEFORE AND THE HEAT FROM THE FIRE PREVENTED HIM FROM LIFTING THE HOOD LATCH. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THE FIRE WAS BURNING ON THE FLOOR OF THE FRONT DRIVERS SIDE. THE VEHICLE WAS DESTROYED. THE CONTACT DID NOT SUSTAIN ANY INJURIES AND WAS ABLE TO EXIT THE VEHICLE. THE VEHICLE WAS TO BE FURTHER INSPECTED AND DIAGNOSED BY THE MANUFACTURER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
Nov 20, 2014
MY TRUCK HAS 2 PARTS THAT HAVE GONE BAD, THE AIR INJECTION PUMPS AND AIR SWITCHING VALVES. TOYOTA ISSUED A WARRANTY POLICY BULLETIN REGARDING THESE PARTS ON TUNDRA MODELS 2007-2010 AND 2008-2010 SEQUOIA MODELS. MY 2005 TUNDRA WAS NOT INCLUDED IN THIS CUSTOMER SUPPORT PROGRAM. HOWEVER, MY TRUCK HAS THE SAME PART THAT IS ON THE 2007-2010 TUNDRAS AND HAS MALFUNCTIONED. THIS IS AN ISSUE THAT TOYOTA HAS BEEN AWARE OF AND THAT WAS THE REASON FOR THE WARRANTY ENHANCEMENT FOR THESE PARTS ON THE 2007-2010 TUNDRAS. TOYOTA HAS REFUSED TO INCLUDE THE 2005 MODELS IN THE SAME CUSTOMER SUPPORT PROGRAM TO REPLACE THESE DEFECTIVE PARTS, THEY HAVE SAID THEY WOULD PAY ONLY HALF OF THE COSTS TO REPLACE THEM. IF ITS THE SAME PART AS THE 2007-2010 THAT TOYOTA KNOWS WERE DEFECTIVE, THEN WHY NOT INCLUDE ALL MODEL TUNDRAS AND SEQUOIAS THAT HAVE THESE PARTS? THE WARRANTY ENHANCEMENT WAS EXTENDED TO 10 YEARS/150,000 MILES. MY 2005 HAS APPROXIMATELY 121,000 MILES AND WAS CHECKED BY MY LOCAL DEALERSHIP WHOM REPORTED THE PROBLEM TO ME AND STATED WHAT THE DEFECTIVE PARTS WERE AND THEY ALSO GAVE ME THE INFORMATION REGARDING THE CUSTOMER SUPPORT PROGRAM(ZTQ). PLEASE GIVE FEEDBACK TO WHATEVER YOU MAY FIND OUT. THANK YOU, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Apr 15, 2013
+ 3 more complaints for this component
ENGINE
6 complaints
Suddenly unintended acceleration has happened multiple times with the brake depressed and the accelerator pedal not depressed.
Oct 28, 2025
CHECK ENGINE LIGHT SECONDARY AIR INTAKE THIS WAS A RECALL IN 2007-10 YEARS BUT IS ALSO BEEN A COMMON PROBLEM IN EARLIER MODELS. THIS IS A VERY EXPENSIVE REPAIR.
Apr 01, 2019
TOYOTA HAS EXTENDED ITS WARRANTY FOR THE AIR INJECTION PUMP AND AIR SWITCHING VALVES ON 2007-2010 TUNDRAS. THE EXTENSION IS FOR 10 YEARS OR 150,000 MILES FROM FIRST USE. I HAVE A 2005 TUNDRA THAT HAS A FAILING AIR INJECTION SYSTEM. I AM WITHIN THE MILEAGE RANGE OF FIRST USE . THE TRUCK HAS THE SAME AIR INJECTION SYSTEM AS THE TUNDRAS WITHIN THE WARRANTY EXTENSION, BUT TOYOTA REFUSES TO HONOR THE WARRANTY EXTENSION ON MY TRUCK. THIS IS A $4000 FIX AND THE TRUCK IS UNSAFE TO DRIVE IN THE CURRENT STATE. *TR
Jan 13, 2015
CHECK ENGINE LIGHT CAME ON AND THE TRUCK LOST POWER. THE ENGINE REVVED LIKE IT WAS TRYING TO GO, BUT HAD NO MORE FORWARD MOMENTUM. THE SPEED AT THE TIME OF THE INCIDENT WAS 50MPH. HOOKED UP THE COMPUTER AND THE ERROR CODE READ THAT IT IS THE AIR SWITCHING VALVE. ERROR CODES P-1442, SWITCHING VALVES ARE STUCK CLOSED, #2 IN BANK 1 AND #2 IN BANK 2 OF THE SECONDARY AIR INSPECTION SYSTEM. SAME ISSUE ON 2007-10 TUNDRA AND WAS RECALLED DUE TO DEFECT. MY TRUCK HAS THE SAME ISSUE, HAS UNDER 150,000 MILES, AND HAS BEEN VERY WELL MAINTAINED. TOLD BY TOYOTA THAT IT IS NOT A RECALL AT THIS TIME AND IF THERE IS ONE IN THE FUTURE, THEY WILL REIMBURSE US OUR COSTS. DRIVING DOWN A TWO LANE HIGHWAY WITH 18 WHEELERS BEHIND YOU AND LOSING POWER, GOING 65-70MPH, IS GOING TO CAUSE A WRECK. I DON'T KNOW HOW TOYOTA WOULD REIMBURSE ME MY HUSBAND. *TR
Apr 09, 2014
LOSS OF POWER DEALER SAID I NEED A SECONDARY SMOG PUMP AND CHECK VALVES AT A COST OF 2158.90 TRUCK HAS ONLY 38000 MILES FIND OUT IF MY INFO IS CORRECT SAME PROBLEM ON 2007 THRU 2010 AND TOYOTA DID EXTEND THERE WARRANTY. LOSS OF POWER A BIG SAFETY ISSUE. *TR
Mar 17, 2013
+ 1 more complaint for this component
STEERING
6 complaints
Ever since I got it 2 years ago the steering has not been right with random vibration from the steering wheel to feeling like im trying harder to make it go straight. And also a clunk at low speed turns/ vibration on freeway. I was told the rack was going so I replaced it with new poly bushings and tie rods. Helped a little but no, got new rims and tires and no difference still vibration on freeway. It's weird if I pull down on the steering wheel it makes it less worse. Also it feels like all this is wearing my power steering pump as it's the only thing covered in oil under my hood. I'm. Seriousy scared to drive it on the freeway cause of the over correcting and vibration. I only have 82k on it. When I got it from the dealership nothing was said. I'm the second owner.I still have the original rack but the problem is still there. Service was done by independent shop. Airbag stickers on passenger visor are gone and passenger airbag cover sticks out more the it should I think. I received the car facts from the dealership and nothing is in there for all the recalls. As the website says there are none pending. I would like to get a print out of ALL recall repairs if possible. I still have the car fax from them.
May 24, 2021
FOR A WEEK I HAD NOTICED A LEAK ON THE SURFACE OF THE PARKING LOT OF MY APARTMENT BUILDING WHERE I ALMOST ALWAYS PARK MY TRUCK. SINCE IT'S AN APARTMENT, I DIDN'T PAY MUCH ATTENTION TO IT, THINKING IT WAS SOMEONE ELSE'S VEHICLE. THEN ON SUNDAY AUGUST 31ST, I HAD DRIVEN ROUND TRIP TO AKRON, OHIO AND BACK TO WILLOUGHBY, OHIO AND NOTICED A HUGE LEAK. I TOOK IT TO THE DEALER WHO SAID IT WAS THE POWER STEERING AND THAT THERE ARE TWO OF THE PARTS THAT NEED TO BE REPLACED. I RESEARCHED THIS PROBLEM AND FOUND THEY HAVE RUSTED AND LEAKED ON OTHER TUNDRA'S OF THE SAME YEAR AS MINE. *TR
Sep 04, 2014
STEERING RACK FAILED SAFETY INSPECTION DUE TO LEAKING POWER STEERING FLUID CAUSED BY RUST. THE DEALERSHIP I WAS USING HAD 3 OTHER OF THE SAME OR SIMILAR TOYOTA TRUCKS WITH THE SAME FAILURE AT THIS SAME TIME. THEY HAD PROBLEMS LOCATING ENOUGH PARTS TO DO ALL THE REPAIR. *TR
Apr 26, 2014
TOOK TO THE SHOP "MEINKE" AND WAS LISTED AS; REPLACE THE LEAKING POWER STEERING RACK AND PINION GEAR - $975.00. *TR
Mar 21, 2014
WHILE STARTING FROM A STOP, EITHER IN DRIVE OR REVERSE, I HEARD A SQUEALING SOUND WHEN TURNING THE WHEELS TO THE LEFT. I AM ALSO LOSING POWER STEERING FLUID, AND MY RIGHT SIDE RACK & PINION BOOT APPEARS TO BE FILLING WITH FLUID. IT APPEARS THAT MY POWER RACK & PINION SYSTEM IS FAILING, AND THE VEHICLE HAS ONLY 55,000 MILES ON IT WITH NO HARD USE (JUST TRANSPORT, MOSTLY LOCAL.) I AM WORRIED THAT MY STEERING SYSTEM MAY FAIL WHILE DRIVING. NOTE: I AM SCHEDULING AN INSPECTION OF THE STEERING ISSUE WITH A LOCAL TOYOTA DEALERSHIP. *TR
Jul 15, 2013
+ 1 more complaint for this component
FUEL/PROPULSION SYSTEM
4 complaints
I FILLED MY GAS TANK (17 GALLONS), DROVE ABOUT 4 MILES AND WAS PULLING INTO A PARKING LOT WHEN I HEARD A GRINDING SOUND, I LOOKED UNDER THE TRUCK AND SAW THE STRAPS HOLDING MY GAS TANK HAD SNAPPED IN HALF AND MY GAS TANK WAS LAYING ON THE GROUND. I HAD RECENTLY RECIEVED A LIMITED SERVICE CAMPAIGN LETTER FROM TOYOTA NOTIFIYING ME THAT "VEHICLES OPERATED IN COLD CLIMATES WITH HIGH ROAD SALT USE MAY EXHIBIT MORE-THAN-NORMAL CORROSION TO THE VEHICLES FRAME" "WHICH MAY CONTRIBUTE TO THE DEVELOPMENT OF MORE THAN NORMAL RUST IN THE FRAME OF SOME VEHICHLES". THE DEALERSHIP ORDERED NEW GAS STRAPS AND ALSO DID THE INSPECTION WHICH RESULTED IN THE UNDER CARRIAGE BEING RE-SPRAYED WITH A CORROSION-RESISTANT COMPOUND. I CONTACTED THETOYOTA CUSTOMER EXPERIENCE CENTER AT THE DEALERSHIPS URGING AND WAS TOLD THIS WAS MY FAULT, IF I HAD BROUGHT MY TRUCK IN FOR REGULAR MAINTENANCE IT WOULD HAVE BEEN DISCOVERED AND REPAIRED. I HAVE OWNED MANY VEHICLES AND NEVER HAD A GAS TANK FALL OFF. MY CONCERN IS THIS COULD HAVE BEEN AT MINIMUM AN ENVIRONMENTAL DISASTER OR AT MAXIMUM AN EXPLOSION COULD HAVE OCCURED.
Jun 15, 2015
I BOUGHT MY TRUCK NEW AND HAD EVERY SCHEDULED MAINTENANCE PERFORMED. THE SECONDARY AIR INJECTION SYSTEM HAS FAILED AND THE TRUCK IS IN LIMP MODE AND WILL NOT DRIVE OR PASS EMISSIONS. I HAVE BEEN TOLD THE REPAIR IS AROUND 3500 AND THE DEALER NOR TOYOTA CORPORATION WILL TAKE RESPONSIBILITY FOR THE FAULTY PART. EVEN THOUGH THEY KNOW IT HAS BEEN A PROBLEM FOR YEARS AND THEY EXTENDED THE WARRANTY ON 2007 THRU 2010 MODELS WHICH USE THE SAME PARTS. I AM TRYING TO TAKE LEGAL ACTION TO GET SOME RESOLUTION.
Jan 06, 2015
I NOTICED A GAS LEAK UNDER THE VEHICLE. TECHNICIAN TOLD ME IT IS DANGEROUS TO DRIVE THE VEHICLE WITH GAS LEAK. DEALER REFUSES TO REPAIR IT AS HE CLAIMS THAT IT IS NOT MANUFACTURER'S DEFECT. *JS
Dec 30, 2014
QUOTED FOR ALMOST 4000 TO FIX THIS MANIFOLD AIR INJECTION MANIFOLD. RESEARCHED ONLINE AND FOUND OUT IT TO BE A COMMON PROBLEM WITH THIS CAR DUE DEFECT. I DON'T UNDERSTAND WHY THEY RECALLED 2007 AND NEWER BUT NOT THE OLDER ONES WHICH SEEMS TO HAVE THE SAME PROBLEM. I HOPE YOUR AGENCY CAN ASSIST US WITH THIS ISSUE. *TR
Nov 03, 2012
VISIBILITY
4 complaints
TL*THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED THAT THE WINDSHIELD DISPLAYED A BUBBLE AFFECT IN THE GLASS DISRUPTING HIS VISION. THE CONTACT TOOK THE VEHICLE TO AN AUTHORIZED TOYOTA DEALER AND WAS INFORMED THAT THE FAILURE WAS NOT RELATED TO ANY EXISTING RECALLS. THE FAILURE MILEAGE WAS 32,000 AND THE CURRENT MILEAGE WAS 35,000.
Mar 24, 2010
TL*THE CONTACT OWNS A 2005 TOYOTA TUNDRA. WHILE DRIVING 45 MPH, THE REAR WINDOW SHATTERED IN THE VEHICLE. THE CONTACT COVERED THE WINDOW WITH A SLEEPING BAG AND DROVE TO HER RESIDENCE. THROUGH ONLINE RESEARCH, SHE NOTICED NUMEROUS COMPLAINTS FOR THE SAME FAILURE SHE EXPERIENCED. THE MANUFACTURER STATED THAT THERE WERE NO RECALLS; THEREFORE, THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIR. THE VEHICLE HAS NOT YET BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 48,000. UPDATED 03/17/09. *LJ UPDATED 03/17/09.*JB
Feb 19, 2009
WINDSHIELD WIPER MOTOR FAILED TO WORK. 6 MONTH OLD TRUCK AND THE WINDSHIELD WIPER MOTOR ASSEMBLY FAILED. TOYOTA FIXED IT UNDER WARRANTY. HAD TO WAIT 2 DAYS FOR THE PARTS. 10 MONTH LATER THE WINDSHIELD WIPER MOTOR FAILED AGAIN. THIS IS A TRUCK WITH LESS THEN 20K MILES. IN BOTH CASES I HAD TO DRIVE HOME IN THE RAIN WITHOUT ANY WIPERS. 1ST INCIDENT 2/22/06, 2ND 12/25/06. *NM
Dec 25, 2006
WINDOWS ARE VERY LOOSE AND RATTLE EXCESSIVELY. TRUCK HAS BEEN TO DEALER SEVEN TIMES, THEY DID HAVE A BULLETIN ON THE WINDOW REGULATOR AND REPLACED IT BUT IT WAS NOT THE SOURCE OF THE PROBLEM. DEALER GAVE UP ON THE PROBLEM AND SAID IT COULD NOT BE FIXED. *JB
Jan 14, 2006
SUSPENSION,UNKNOWN OR OTHER
3 complaints
THIS VEHICLE WAS RECALLED FOR FRAME RUST ISSUES. THE DEALER UNDER COATED THE FRAME IN-LIEU OF REPLACING IT, AS THEY HAVE DONE WITH SO MANY OTHERS. NOW I'M FACING A SAFETY ISSUE, AS THE FRAME HAS RUSTED THROUGH IN CRITICAL AREAS. THE MAJOR CONCERN IS IF THE FRAME SNAPS IN HALF WHILE UNDER HIGH SPEEDS CAUSING AN ACCIDENT AND POTENTIALLY INJURING OTHER AND OR MYSELF. I HAVE CONTACTED THE MANUFACTURER AND THEY PROVIDED A CASE NUMBER (240530000550). THE DEALER IS AWARE OF THIS ISSUE AND THEY WERE THE ONES THAT RECOMMENDED CONTACTING THIS ORGANIZATION AS WELL AS THE MANUFACTURER.
May 30, 2024
I own a 2005 Toyota Tundra 4dr. and in January of this year 2022 a recall was sent out on ‘Inadequate Hardness of Ball Joint Housing’. My Tundra is having ball joint problems meaning skeeking on the front wheels, vibrating until over 55 mph., and suspension problems. I called a Toyota dealership to get the truck fixed but they told me that back in 2007 the ball joints were already fixed. I shouldn’t be having this problem if the recall just came out. I’m trying to get this problem corrected on my truck without having to pay the $900 bill they want to charge me to fix it. Whst can I do ??
Aug 31, 2022
Perforations in frame along seams due to rust isolated to the driver side front frame rail. Toyota is aware of this problem and refuse service and repair.
Jun 02, 2021
SUSPENSION,SERVICE BRAKES
3 complaints
I dont know exactly is the front ball joint or something else but something happen when run and stop the tundra, all the time hear a noise how to something is broke
Oct 23, 2021
The leaf springs have broken and frame is showing serious rust damage. Brake lines were leaking and had to be replaced.
Aug 10, 2021
THE FRAME RUSTED TO THE POINT THAT IT WILL NOT PASS A STATE INSPECTION. THE BRAKES WOULD NOT STOP THE VEHICLE WHEN IN FORWARD MOTION, WHICH CAUSED AN ACCIDENT.
Feb 03, 2020
SUSPENSION,POWER TRAIN,STRUCTURE
3 complaints
The frame has several holes in it. Toyota said they did the corrosion prevension on it and said the repair is out of warranty. The sway bar has broken free of the frame and there are several hole and flaking spots on the frame.
May 20, 2021
WHILE DRIVING DOWN THE ROAD MY SPARE TIRE MOUNT FAILED DO TO RUST CORROSION CAUSING MY SPARE TIRE TO FALL OFF OF MY VEHICLE. UPON INSPECTION THE ENTIRE REAR FRAME AS WELL AS PARTS OF THE FRONT ARE CORRODED AND FLAKING CHUNKS OF METAL OFF. THIS RUSTING ALSO AFFECTS SUSPENSION MOUNTS AND THE ENTIRETY OF THE REAR AXLE.
Mar 09, 2021
WE RECEIVED SEVERAL RECALL NOTICES FOR FRAME DETERIORATION AND THE NEED FOR INSPECTION, CORRECTION AND ANTI-CORROSION CHEMICAL APPLICATION. WE TOOK IT TO THE TOYOTA DEALER AS REQUESTED. THEY CALLED THE NEXT MORNING TO HAVE US PICK UP THE VEHICLE AND THE ANTI-CORROSION SPRAY (BLACK GOOEY STUFF SIMILAR TO UNDERCOATING) THAT THEY USED WAS EVERYWHERE, INCLUDING ON THE WIRING HARNESSES, BRAKE LINES, THE STEP BARS THAT WE INSTALLED AFTERMARKET LAST YEAR, INSIDE OF THE WHEEL WELLS, THE MUD FLAPS - IT WAS STILL WET AND SMELLED AWFUL. WE CONTACTED THE SERVICE MANAGER WHO BLEW US OFF, WE CALLED TOYOTA AND THEY REFUSED TO ASSIST, OTHER THAN TO TAKE DOWN THE COMPLAINT ON PAPER. I CAN'T SEEM TO FIND AN ATTORNEY EVEN REMOTELY INTERESTED IN ASSISTING WITH THIS CASE. TOYOTA SAYS THAT THE COATING MAY NEVER DRY SO IT WILL ATTRACT ALL DIRT AND GRIME THAT IT'S EXPOSED TO. IT LOOKS AND SMELLS HORRIBLE. WE CAN'T EVEN SELL IT BECAUSE IT SMELLS SO BAD! TOYOTA WON'T REMOVE IT OR EVEN REPAIR IT, NOR WILL THEY REPLACE THE VEHICLE. *TR
Oct 01, 2014
POWER TRAIN,ELECTRICAL SYSTEM
3 complaints
TUNDRA HAD ELECTRICAL FAULT IN TRANSMISSION DUE TO WIRING HARNESS CORROSION. TUNDRA WILL DROP OUR OF GEAR WHILE DRIVING AND REENGAGE VIOLENTLY. TOYOTA HAS REFUSED ANY ASSISTANCE AND I AM UNABLE TO REPAIR DUE TO NATIONAL BACKLOG ON NECESSARY PARTS. MY TUNDRA WAS PART OF THE RUST RECALL A COUPLE YEARS AGO WHICH WAS NEVER PROPERLY RECTIFIED AND I BELIEVE THIS IS A CONTINUATION OF THAT PROBLEM. TRANSMISSION ISSUE SEEMS TO OCCUR MOSTLY AT SPEEDS UP TO 45 MPH.
Jan 28, 2019
THE CONNECTOR ON THE CABLE FROM THE ECU TO THE TRANSMISSION FAILED DUE TO CORROSION. THIS CAUSES THE TRUCK TO ACCELERATE FROM A STANDING STOP IN A MANNER WHERE THE TRANSMISSION SLAMS IN AND OUT OF GEAR. THANKFULLY THIS DIDN'T OCCUR WHEN PULLING OUT ON A BUSY STREET. THE SITUATION IS DANGEROUS. THE TRUCK ALREADY HAD A FRAME RECALL DUE TO CORROSION. THIS ISSUE IS SIMILAR AND REPRESENTS A DESIGN FLAW WITH DANGEROUS CONSEQUENCES. *TR
Feb 19, 2015
MY TOYOTA TUNDRA 2005, V8, 4.7L, 4X4(83,000 MILES) LOST ITS TRANSMISSION POWER WHILE DRIVING ON THE HIGHWAY AND THE CHECK ENGINE LIGHT CAME ON. THE TRANSMISSION POWER CAME ON AND OFF ALL THE WAY HOME. LUNGING EACH TIME IT DROPPED OFF AND CAME ON. I BROUGHT IT TO THE DEALER WHO TOLD ME I NEEDED A NEW TRANSMISSION AT A COST OF $4000.00. IT WAS DISPLAYING P0986 CODE. THE NEXT DAY BROUGHT IT TO A TRANSMISSION SHOP. THEY FOUND THAT THE WIRE CONNECTOR (15 PIN) THAT GOES FROM THE TRANSMISSION TO THE ECM WAS CORRODED AND THE PINS WERE BROKEN AND NOT MAKING CONTACT. ITS DESIGN IS CLEARLY DEFECTIVE. IT IS NOT PROTECTED AND IS LOCATED IN A PLACE WHERE IT IS EXPOSED TO ALL THE SALT AND WATER RESULTING IN THE PINS BEING CORRODED. INFORMATION COMMUNICATED FROM THE COMPUTER TO THE TRANSMISSION AND BACK IS INTERRUPTED OR INACCURATE. I FOUND THIS INFORMATION ON A WEBSITE AT THE SAME TIME THE INDEPENDENT TRANSMISSION SHOP DISCOVERED WHAT THE PROBLEM WAS. THE FOLLOWING SITE DESCRIBES THE PROBLEM VERY CLEARLY WITH PICTURES AND DESCRIPTIONS: HTTP://WWW.TECHNO-FANDOM.ORG/~HOBBIT/CARS/TUNDTRAN/ I CONTACTED TOYOTA. THEY GAVE ME A RUN AROUND WITH ONLY FRUSTRATION AND STRESS. I SEE THIS PROBLEM OCCURRING WITH ALL THESE TRUCKS IN ANY PART OF THE COUNTRY WHERE IT IS WET. I FEEL TOYOTA SHOULD PAY FOR THE FIX AND NOT ME. IT IS A MAJOR PROBLEM AND CAUSES UNEXPECTED POWER LOSE OR TRANSMISSION FAILURE WHEN DRIVING. PLEASE LET ME KNOW ASAP IF YOU WANT THE OLD PART AFTER THE NEW ONE IS INSTALLED. IT SHOULD HAPPEN IN A FEW DAYS. *TR
Jan 09, 2010
SUSPENSION,STRUCTURE,UNKNOWN OR OTHER
2 complaints
Frame and suspension is rotted away badly was recall on frame In 2005
Jan 23, 2024
2005 TUNDRA FRAME IS RUSTED IN MANY PLACES. VERY BAD WHERE FRAME SECTIONS MEET AND NOW THE FRAME IS RUSTING THROUGH THE MAIN HORIZONAL FRAME ITSELF AS THE ATTACHED PICTURE INDICATES. THIS HAS BEEN AN ONGOING ISSUE FOR YEARS BUT IS BAD ENOUGH NOW THAT IT IS NOT SAFE AND WILL NOT PASS INSPECTION. I KNOW THERE WAS A RECALL ON THIS FRAME AND I WAS TOLD IT WAS OK WHEN I BROUGHT IT IN FOR THE RECALL. I T HAS BEEN RUSTING EVER SENSE. WE HAVE ONLY PURCHASED TOYOTAS AND LEXUS VEHICLES FOR THE LAST 20 OR MORE YEARS AND THIS IS THE THIRD TRUCK RUST HAS TOTALED. PLEASE HELP
Apr 06, 2021
STRUCTURE,UNKNOWN OR OTHER
2 complaints
I seen that Toyota were recalled for the frame issues on 2004 and up, mine is 2005 tundra with frame issues, like it’s sad, such a nice truck, but frame is horrible. Why is mine not being shown as recalled, but yet I have frame problems? I got my truck from a 1 owner who had it since new, it just hit 100,000 miles on it, it was serviced by Toyota dealership, I’m not sure why they didn’t do nothing with it over the years to help or fix the rust issue on the frame. It’s not just a little rusty, it’s really rusty, and it was garage kept too. Did they forget to include my vin number when they started the recalls? Doesn’t make sense why they would fix some and not all, all around the same years. Thanks Jim
Jun 14, 2021
THE FRAME OF THE TRUCK WAS RECALLED FOR EXCESSIVE RUST. THE DEALER SPRAYED ON A COATING PER THE RECALL IN 2013. THE COATING HAS ALL FLAKED OFF AND THE FRAME IS LOSING CHUNKS OF RUST. TOYOTA KNOW ABOUT THIS PROBLEM BUT WON'T DO ANYTHING ABOUT IT ONCE THEY SPRAY THE DEFECTIVE COATING ON IT. THE TRUCK FRAME NEEDS REPLACED AND THEY WON'T DO IT. SOMEBODY IS GOING TO BE SERIOUSLY INJURED OR KILLED IN ONE OF THESE TRUCKS WHEN THE FRAME BREAKS AT SPEED.
Nov 04, 2016
STRUCTURE,SERVICE BRAKES
2 complaints
TOYOTA TUNDRA FRAME RECALL - FRAME COATING APPLIED PER RECALL IN 2014. VEHICLE INSPECTED TWICE BY DEALER IN 2018 & 2019 AND VEHICLE DETERMINED TO BE OK. RECENTLY EXPERIENCED LOSS OF BRAKES AND CRASH INTO GARAGE. VEHICLE INSPECTED BY INDEPENDENT MECHANIC AND FOUND 2 PERFORATED AND RUSTED BRAKE LINES. SCRAPING AWAY THE UNDERCOATING UNCOVERED OTHER CORROSION IN VARIOUS DEGREES. DETERMINED THAT SPRAY UNDERCOATING CAME WAY TO LATE AS TRUCK ALREADY HAD 9 YEARS OF CORROSION. UNDERCOATING ONLY HID THE PROBLEM. SUBMITTED A CLAIM WITH TOYOTA WHO OFFERED NO ASSISTANCE.
Aug 06, 2019
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED THAT THE SERVICE BRAKE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT CHECKED THE FLUID LEVEL AND NOTICED THAT THE BRAKE FLUID WAS NEARLY DEPLETED. THE CONTACT REPLENISHED THE FLUID AND THE LIGHT DIMMED. WHEN THE BRAKE PEDAL WAS DEPRESSED, IT SANK TO THE FLOORBOARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THE ENTIRE UNDER CARRIAGE WAS EXCESSIVELY CORRODED AND THE BRAKE LINES FRACTURED. THE MANUFACTURER AND DEALER WERE MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 36,121. UPDATED 01/20/15*LJ UPDATED 01/10/15. *JB UPDATED 02/05/15*JB UPDATED 03/10/15*LJ UPDATED 06/17/2015 *JS
Dec 10, 2014
SEAT BELTS
2 complaints
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED THAT THE FRONT DRIVER AND PASSENGER SEAT BELTS FAILED TO RETRACT. THE VEHICLE WAS TAKEN TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE SEAT BELT MECHANISM NEED TO BE TORQUED TO SPECIFICATIONS. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS ALSO CONCERNED THAT THE FAILURE WAS PRESENT ON THE 2002 TOYOTA SEQUOIA MODEL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.
Aug 26, 2016
TL*THE CONTACT OWNS A 2005 TOYOTA TUNDRA. EVER SINCE THE VEHICLE WAS PURCHASED, THE SAFETY BELT SENSOR LIGHT HAS BEEN ILLUMINATED. THE VEHICLE HAD A FAULTY SAFETY BELT SYSTEM. THE RED SENSOR LIGHT ILLUMINATES WHEN THE VEHICLE IS STARTED AND REMAINS LIT. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THEY WANTED TO GIVE HIM A COMPUTER MODULE FOR THE SENSOR. THE COMPUTER MODULE WAS NOT REPLACED BECAUSE THE CONTACT WANTED ALL THREE SENSORS REPLACED, NOT JUST THE SAFETY BELT SENSOR. THE CURRENT MILEAGE WAS 22,700 AND FAILURE MILEAGE WAS 5.
Oct 24, 2007
WHEELS
2 complaints
I HAVE BEEN HAVING THIS SCREECHING NOISE FROM THE FRONT UNDER THE HOOD NEXT TO THE TIRES. WHEN DRIVING I FELT ITS VIBRATION AND THE FRONT WHEELS WERE ABOUT TO COME OFF. I TOOK IT TO MY MECHANIC TO LOOK AT IT AND HE TOLD ME THAT THE BOLT JOINTS ON BOTH SIDE OF THE FRONT ARE ABOUT TO COME OFF. HE TOLD ME THAT HE HAD SEEM CUSTOMERS WHEELS CAME OFF THE FREEWAYS. ON FEBRUARY 6, 2014, I HAVE THE BOLT JOINTS REPLACED IN THE TOTAL AMOUNT OF $1,014.98. WITH THIS ISSUE, I AM VERY CONCERN WHY TOYOTA HAS NOT RECALL THIS PROBLEM. MY PROBLEM COULD HAVE BEEN WORSE IF I WAS DRIVING ON THE FREEWAY AND THE WHEELS COME OFF. WHO KNOWS WHAT WOULD HAVE HAD HAPPENED. ALL I WANT IS TO HAVE THIS MATTER SOLVED BY TOYOTA PAY MY SERVICE BILL. *TR
Mar 11, 2014
2005 TOYOTA TUNDRA DOUBLECAB, PAINT ON WHEELS STARTED BUBBLING,CAUSING LOSS OF AIR PRESSURE IN TIRES, HAD RIMS CLEANED OF PEELING PAINT, ALL 4 WHEELS CONTINUE TO LEAK AIR. CAUSING DIFFERENT AIR PRESSURE IN TIRES AND CAUSING TIRES TO GO FLAT. *TR
Dec 09, 2012
ENGINE AND ENGINE COOLING,VEHICLE SPEED CONTROL
2 complaints
LOSS OF ACCELERATION POWER. DEALER QUOTE $3,745 TO REPLACE PUMP/VALVE/DRIVER ASSEMBLIES. TOLD BY REPAIR SHOP SAME ISSUE AS TECHNICAL BULLETIN ADDRESSED ON 2007-2010 TUNDRAS POWER ISSUES. IF TRUE, SEEMS A RECALL SHOULD HAVE BEEN REQUIRED TO REPAIR 2005 YEAR MODELS. *TR
Jan 27, 2014
2005 TOYOTA TUNDRA EXPERIENCE ELECTRONIC FAILURE*CW THE CONSUMER STATED THE MECHANICAL OR ELECTRONIC FAILURE CAUSED AN ACCIDENT AS WELL AS INJURIES. THE CONSUMER STATED ALL HE REMEMBERED WAS EXITING THE HIGHWAY IN EVENING TRAFFIC WHEN ALL OF A SUDDEN, HIS VEHICLE RAMMED INTO THE VEHICLE IN FRONT OF HIM. THE AIR BAGS DEPLOYED PRIOR TO THE COLLISION AND HE HAD NO RECOLLECTION OF BEING ABLE TO BRAKE. HE ALSO STATED THE ENGINE FAILED IN JUNE 2009. THE CONSUMER WAS INFORMED THERE MUST HAVE BEEN SOMETHING WRONG WITH THE SEAMS IN THE RADIATOR. APPARENTLY, IT BLEW OUT THE BOTTOM, WHICH CAUSED THE INSTANTANEOUS LOSS OF THE RADIATOR FLUID. *JB
Mar 12, 2010
SEATS
2 complaints
TL*THE CONTACT OWNS A 2005 TOYOTA TUNDRA. WHILE STOPPED AT A TRAFFIC LIGHT, THE CONTACT'S VEHICLE WAS HIT FROM THE REAR. THE CONTACT STATED THAT THE METAL SUPPORT IN THE HEAD REST CAME THROUGH THE PADDING AND HIT HIM IN THE HEAD, CAUSING HIM TO LOSE CONSCIOUSNESS. A POLICE REPORT WAS FILED. THE HEAD REST HAD NOT BEEN REPAIRED PER THE MANUFACTURER'S REQUEST. THE FAILURE MILEAGE WAS APPROXIMATELY 113,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 115,000.
Dec 09, 2010
DRIVERS CAPTAIN CHAIR CONTINUALLY MOVES AND MAKES A POPPING NOISE EVERYTIME I STOP AND GO.
Jul 21, 2006
SERVICE BRAKES, HYDRAULIC,VEHICLE SPEED CONTROL
2 complaints
I HAVE EXPERIENCED FLOOR MAT ENTANGLEMENT ISSUES AND UNCOMMANDED ACCELERATIONS WITH MY 2005 TUNDRA DOUBLE CAB. I ALSO HAVE EXPERIENCED A CLUNKING SOUND IN MY BRAKES/FRONT END WHEN I SHIFT INTO REVERSE AND THEN APPLY THE BRAKES. THE DEALER HAS TOLD ME ALL OF THESE ISSUES ARE NORMAL WHICH ACCORDING TO THE RECALLS FOR OTHER MODEL YEARS THEY ARE CLEARLY NOT NORMAL. CAN THE 05 TUNDRAS BE ADDED TO THE CURRENT RECALLS AND CAN THE BRAKE ISSUE BE ADDRESSED? *TR
Feb 25, 2010
TL*- THE CONTACT STATED THAT ON TWO SEPARATE OCCASIONS WHILE DRIVING THE 2005 TOYOTA TUNDRA WITH 28,000 FAILURE MILEAGE THE VEHICLE LURCHED FORWARD WITH HIS FOOT DEPRESSED ON THE BRAKE PEDAL. THE IGNITION HAD TO BE TURNED OFF TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER, AND THEY FOUND NOTHING WRONG. THE CONTACT RECEIVED RECALL 05V123000 PERTAINING TO VEHICLES WITH DUAL EXHAUST. *AK
Apr 02, 2007
SUSPENSION,FUEL/PROPULSION SYSTEM
1 complaint
Frame is rusted beyond repair both in the front and rear of the truck. fuel tank strap is rusted threw and fuel tank is hanging by one strap and not far from the ground.
Aug 13, 2024
STEERING,SUSPENSION,UNKNOWN OR OTHER
1 complaint
Frame corrosion through out the entire frame. Recently the steering rack broke away from the frame cross member. Now every time I turn the wheel there is a popping sounds and the steering feels loose compared to what it did before the sound accord. There is also a hole in the back of the frame behind the back tire. My attached tow package ripped sections of the frame and caused crack to extend towards the front of the frame. The fuel tank straps are also severely corroded.
Feb 15, 2024
SUSPENSION,POWER TRAIN,UNKNOWN OR OTHER
1 complaint
It’s has come to my attention that this is an on going issue with tundra frames rusting out after being sprayed I inherited this truck from a family friend and the truck is getting to where it’s not drivable for frame issues this needs to be addressed by Toyota ASAP!!
Jan 09, 2023
UNKNOWN OR OTHER,SERVICE BRAKES,FUEL/PROPULSION SYSTEM
1 complaint
Gas tank Strap rusted thru and broke. Brake lines rusted thru and leaked Differential rusted thru and leaked. Frame excessively and extensively rusted.
Sep 01, 2021
STEERING,SUSPENSION
1 complaint
CATASTROPHIC BALL JOINT FAILURE (DRIVER SIDE UPPER BALL JOINT) WHILE DRIVING AT SLOW SPEED.
Mar 04, 2021
SUSPENSION,SEAT BELTS,ENGINE
1 complaint
AT SPEEDS ABOVE 50+ THE REAR END CONSTANTLY RUMBLES AND SHAKES THE WHOLE TRUCK. AND WHEN PRESSING THE BREAK IT DOES AS WELL. SEAT BELT LOCKS WHEN TRYING TO PUT IT ON. PARKING BRAKE DOESN'T WORK. WHINING AND SQUEAKY NOISE IN THE REAR END. CLUNKING NOISE AT LOWER SPEEDS. ENGINE LIGHT IS ON & WON'T GO OFF. TIRE PRESSURE SENSOR DOESN'T WORK. REAR END SEAL LEAK. DRIVER SIDE WINDOW FEELS LIKE IT'S GONNA FALL OUT. TRUCK IS WAY TOO LOUD AND EVERYTHING IS STOCK. AC/HEAT BEING ON MAKES LOUD NOISE.
Oct 08, 2020
STEERING,SUSPENSION,POWER TRAIN
1 complaint
I TOOK THIS TRUCK INTO MY LOCAL TOYOTA DEALER ON JULY 09, 2015 AS PART OF A RECALL FOR A FRAME INSPECTION. THE MILEAGE AT THAT TIME WAS 295,801. THE DEALER SAID THE FRAME WAS IN GOOD SHAPE AND APPLIED A CORROSION INHIBITOR AS PART OF THE PROGRAM. IN FEBRUARY OF THIS YEAR, (2020) I DECIDED TO INSTALL NEW BREAK PADS. WHEN I REMOVED THE WHEEL ON THE DRIVER SIDE, I FOUND A SIGNIFICANT HOLE IN THE FRAME AND CRACKING ALL AROUND THE AREA. IN APPROXIMATELY 5 YEARS AND 17,000 MILES, THIS DEVELOPED. I HAVE NOT DRIVEN THE TRUCK IN THE WINTER FOR ABOUT 8 YEARS AS THIS BECAME A SECONDARY VEHICLE ONLY FOR SUMMER PROJECT USE AROUND THE HOME. I CONTACTED TOYOTA CORPORATE AND THEY SAID THAT THERE WEREN'T ANY PROGRAMS AVAILABLE TO REMEDY THE SITUATION AND I WAS BASICALLY OUT OF LUCK. I RECENTLY TOOK THE TRUNK TO A FRAME & BODY SHOP AND WAS SHOWN MUCH MORE EXTENSIVE FAILURE IN THE FRAME ON BOTH SIDES. HE DETERMINED THE FRAME IS UNREPAIRABLE BECAUSE OF THE AMOUNT OF ROT AND THE TRUCK WILL NEED A COMPLETE NEW FRAME. I CAN'T BELIEVE THAT IN 5 YEARS DRIVING, AVERAGING 3,400 MILES A YEAR THAT THE FRAME WENT FROM GOOD (AS THE DEALER DESCRIBED IT) TO BEING UNDRIVEABLE. TOYOTA NEW THE STEEL WAS BAD IN MANY OF THEIR TRUCKS AND SUV;S BUT HAS REFUSED TO REPAIR ALL THAT WERE AFFECTED BY THE BAD STEEL AND LACK OF PROTECTION APPLIED DURING MANUFACTURING. I HAVE HAD TO PULL THE TRUCK OFF THE ROAD AS IT HAS BECOME UNSTABLE AND HAZARDOUS TO DRIVE.
Jul 31, 2020
POWER TRAIN,UNKNOWN OR OTHER
1 complaint
THE FRAME AND CROSS MEMBERS ARE DETERIORATED TO THE POINT OF BREAKING. THE FRONT DRIVESHAFT AND STEERING LINKAGE IS EXCESSIVELY DETERIORATED. THE BRAKE AND FUEL TANK BRACKETS ARE ALSO DETERIORATED AND ARE FAILING TO SUPPORT ATTACHED COMPONENTS
May 10, 2020
VEHICLE SPEED CONTROL,ENGINE,FUEL/PROPULSION SYSTEM
1 complaint
2005 TOYOTA TUNDRA DOUBLE CAB. WHEN STATIONARY ON COLD START: VEHICLE PRODUCES A LOUD NOISE AND ADDITIONAL CARBON MONOXIDE/EXHAUST, CAUSING ADDITIONAL DANGER WHEN STARTING IN A GARAGE. WHEN IN MOTION: TRUCK OPERATES AS INTENDED UNTIL ACCELERATION IS ATTEMPTED, CAUSING A MAJOR SAFETY CONCERN WHEN MERGING ONTO HIGHWAYS, DRIVING UP AN INCLINE, OR ANY OTHER DRIVING SITUATION WHERE THE GAS APPLICATION IS NECESSARY. WHEN IN MOTION: VENTING AND INTERIOR AIR CONTROLS CANNOT BE USED BASED ON THE AMOUNT OF EXHAUST THAT WILL SPILL INTO THE CAB OF THE TRUCK. THIS IS A PROBLEM THAT IS WIDELY KNOWN TO THE TOYOTA COMMUNITY, AND TO DRIVERS OF TOYOTA TUNDRAS IN PARTICULAR. OF NOTE, THOUSANDS OF MESSAGES CAN BE EASILY ACCESSED IN THE TOYOTA MESSAGE BOARDS (TUNDRA TALK, TOYOTA NATION, TUNDRAS.COM, TUNDRA SOLUTIONS). IN ADDITION, THERE IS A SEPARATE COTTAGE INDUSTRY THAT HAS SPRUNG UP AS A RESULT, WHERE MANUFACTURERS ARE PRODUCING BYPASS KITS THAT COMPROMISE THE EXHAUST STANDARDS SET BY YOU ALL, WHERE AN ENTIRE BUSINESS MODEL HAS BEEN CREATED TO PROFIT OFF OF THESE ISSUES. ONE OF THE PRIMARY PARTIES IS HEWITT-TECH. WHEN ADVISED AT A TOYOTA DEALERSHIP, THE REPAIR QUOTE WAS $2568 OUT OF POCKET. WHEN SPEAKING TO TOYOTA CUSTOMER EXPERIENCE, I WAS TOLD THEY DO NOT ANTICIPATE ADDRESSING THE ISSUE, AS IT IS NOT ENOUGH OF A PROBLEM. IN GREATER RESEARCH, IT IS APPARENT THEY ARE EITHER AWARE BUT UNWILLING TO REMEDY THE SITUATION BECAUSE A) THE SCOPE IS FAR TOO WIDESPREAD WITHIN THEIR TRUCK MARKET (EVERY TOYOTA TUNDRA IS SUBJECT TO RECALL) OR B) THE SCOPE IS TOO WIDESPREAD THROUGHOUT THEIR ENTIRE MARKETSHARE (SIMILAR PROBLEMS ARE INDICATED WITH THE COROLLA AND OTHER PASSENGER CARS). THIS IS NEGLIGENT AND DANGEROUS AND NEEDS TO BE ADDRESSED.
Jan 27, 2020
POWER TRAIN,STRUCTURE,ENGINE
1 complaint
I OWN A 2005 TOYOTA TUNDRA WITH JUST 60,000 MILES. IN 2014 TOYOTA WAS ALLOWED TO PUT A BAND-AID ON A PROBLEM THAT NEEDED A TOURNIQUET - APPLYING A RUST CONVERTER COATING TO A FRAME THAT, BECAUSE OF THEIR FAILURE TO MANUFACTURER IT PROPERLY, DESERVED REPLACING. I WAS TOLD BY TOYOTA (CASE NUMBER [XXX]) THAT BECAUSE THE PREVIOUS OWNER TOOK THE BAND-AID THEY WERE NO LONGER LIABLE UNTIL THE GOVERNMENT FORCED THEM VIA FURTHER GOVERNMENT SAFETY RECALL ACTIONS TO DO MORE. MY HOPE IS BY WRITING THIS THAT THE GOVERNMENT CAN BE PROACTIVE AND SOLVE THIS SAFETY CONCERN BEFORE THEY HAVE TO COLLECT ENOUGH DEATH AND ACCIDENT STATISTICS TO TAKE NOTICE OF THIS ISSUE. NOT ONLY THAT, I SEE THAT TOYOTA IS BEING OFFERED THE SAME BAND-AID SOLUTION ON A NUMBER OF NEW MODELS WITH THE SAME ISSUE - PROVING THAT THEY DIDN'T LEARN ANY LESSON JUST HOW THEY CAN GET AWAY WITH ACTUAL MURDER. THE RESULT WILL BE MORE VEHICLES IN 5 YEARS IN WORSE SHAPE DUE TO THE LENIENT RECONCILIATION MANDATED BY THE GOVERNMENT. DO NOT PUT MORE LIVES AT RISK IN ORDER TO SAVE A MULTI-BILLION DOLLAR COMPANIES BOTTOM LINE. THE FRAME WHICH IS KNOWN TO BE PRONE TO EXCESSIVE, PREMATURE RUST CORROSION BECAUSE THE FRAMES WERE NOT PROPERLY PREPARED AND TREATED AGAINST RUST CORROSION WHEN THEY WERE MANUFACTURED SHOULD ALL HAVE TO BE REPLACED UNDER THIS RECALL TO PROTECT AMERICAN DRIVERS. THIS EXCESSIVE RUST CORROSION COMPROMISES THE VEHICLES' SAFETY, STABILITY, AND CRASH-WORTHINESS BECAUSE IMPORTANT SUSPENSION COMPONENTS, ENGINE MOUNTS, TRANSMISSION MOUNTS, AND BODY MOUNTS ANCHORED TO THE VEHICLES' FRAMES ARE AT RISK OF FAILURE. DO YOU WANT THIS VEHICLE (PICTURE ATTACHED) PASSING YOUR FAMILY ON A TWO-LANE HIGHWAY, BECAUSE I CAN TELL YOU THERE ARE A LOT, AND SOON TO BE EVEN MORE, DOING IT EVERY DAY. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Dec 16, 2019
POWER TRAIN,VEHICLE SPEED CONTROL,FUEL/PROPULSION SYSTEM
1 complaint
I PURCHASED THIS VEHICLE USED APROX 10 YEARS AGO. THE ISSUE THAT I HAVE HAD LOOKED AT BY TOYOTA DEALERSHIP REMAINS UNRESOLVED. WHEN YOU TAKE YOUR FOOT OFF THE BRAKE IT IMMEDIATELY LUNGES FORWARD AND TRAVELS WITHOUT FOOT ON THE GAS UP TO SPEED OF 15 MPH ON FLAT LEVEL GROUND. IT IS DEFINITELY NOT SAFE. IT COULD CAUSE?AN ACCIDENT. MY BROTHER'S INSISTED THAT I HAVE IT LOOKED AT BY TOYOTA DEALERSHIP. I HAVE NOT HAD A SATISFACTORY ANSWER TO THIS ISSUE. AGAIN THE ANSWER REMAINS THERE HAS BEEN NO RECALL. COULD IT BE A TIMING CHAIN ISSUE?
Apr 22, 2019
SUSPENSION,ELECTRICAL SYSTEM,UNKNOWN OR OTHER
1 complaint
SERVICE BULLETIN P2445 FOR SECONDARY AIR INGECTION SYSTEM THEN NOTES THE FRAME IS CORROSION AND MOUNTS ARE BRAKING OFF
Apr 11, 2019
STRUCTURE,UNKNOWN OR OTHER,SERVICE BRAKES
1 complaint
MY 2005 TOYOTA TUNDRA HAS 217K MILES AND IS, MECHANICALLY, IN TERRIFIC SHAPE, EXCEPT THE FRAME HAS RUSTED OUT ON THE DRIVERS SIDE. STRUCTURALLY, IT'S STILL DRIVABLE SAFELY, BUT IT WILL NO LONGER PASS STATE INSPECTION (MAINE, USA). THOUSANDS OF OTHER TOYOTA TUNDRAS OF THE SAME STYLE AND MANUFACTURING PROCESS AND SIMILAR MODEL YEAR HAVE HAD FRAME RECALLS DONE FOR THE EXACT SAME REASON. I DO NOT FEEL IT IS FAIR TO SKIP THIS YEAR. THIS IS MY FAMILY'S ONLY SOURCE OF TRANSPORTATION RIGHT NOW, AND IT IS VITAL TO KEEP IT ON THE ROAD. PLEASE ALLOW A FRAME RECALL FOR THIS MODEL YEAR!
Mar 21, 2019
STEERING,SERVICE BRAKES
1 complaint
2005 TOYOTA TUNDRA. CONSUMER WRITES FRONT BRAKE LINE BROKE AND MAJOR RUSTING OF BRAKE LINES, AND RUSTED FRAME. * VA THE CONSUMER STATED THE POWER STEERING METAL LINES STARTED LEAKING. *JS
Feb 27, 2018
STEERING,STRUCTURE,SERVICE BRAKES
1 complaint
MAJOR RUSTING OF FRAME, RUSTED BRAKE LINES, RUSTED POWER STEERING LINES. VEHICLES IS UNSAFE DUE TO RUSTING.
Jan 26, 2018
SUSPENSION,STRUCTURE,SERVICE BRAKES
1 complaint
I HAVE A 2005 TOYOTA TUNDRA, WHICH HAS THE ENTIRE FRAME ALL RUSTED. I ALREADY REPLACED ALL BRAKE LINES AND DIFFERENTIAL BECAUSE OF THE RUST. THE MECHANIC SAID IT IS RUSTED SO BAD THAT IT COULD FALL APART. THERE WAS A LIMITED CAMPAIGN FOR A RECALL ON OUR TUNDRA AND THE SPRAY WAS DONE IN 2015. OBVIOUSLY IT DIDN'T TAKE BECAUSE OF ALL THE CONTINUOUS ISSUES WE ARE HAVING. I CALLED THE CORPORATE OFFICE OF TOYOTA AND OPENED AN CLAIM AND THE MANAGER I SPOKE TO REALLY COULD CARE LESS AND TOLD ME THAT ONCE THE WARRANTIES ARE OVER ITS NO LONGER THEIR (TOYOTA) PROBLEM. I REQUESTED A FIELD INSPECTION TECHNICIAN TO LOOK AT THE TRUCK . THAT REQUEST WAS DENIED BY THE MANAGER WHO STATED THAT HE WAS SPEAKING FOR TOYOTA. I ASKED FOR MY CLAIM TO BE REVIEWED BY SOME ONE ABOVE HIM AND HE STATED THEIR WAS NO ONE HIGHER THEM HIMSELF AND HIS DECISION WAS FINAL. I DON'T UNDERSTAND WHY THEY CAN'T LOOK AT THEIR PRODUCTS AND TELLS US IF IT IS SAFE TO DRIVE. OBVIOUSLY THEY NEW THERE WAS A PROBLEM OR THEY WOULDN'T HAVE THE LIMITED CAMPAIGN FOR A RECALL. THEY NEED TO DO MORE.
Dec 29, 2017
PARKING BRAKE,FUEL SYSTEM, GASOLINE,POWER TRAIN,STRUCTURE
1 complaint
2005 TOYOTA TUNDRA. CONSUMER WRITES IN REGARDS TO REPLACEMENT PARTS NOT AVAILABLE TO REPAIR AIRBAG RECALL NOTICE. *SMD THE CONSUMER STATED THE VEHICLE WAS RETURNED DAMAGED FROM HAVING A RECALL REPAIR COMPLETED. UPDATED 09/14/2017*JS UPDATED 09/14/2017*JS
Sep 14, 2017
STEERING,SUSPENSION,STRUCTURE
1 complaint
THE ENTIRE FRAME OF THE TRUCK AND EVERY COMPONENT DIRECTLY IN CONTACT WITH IT INCLUDING THE SUSPENSION IS AND HAS BEEN OXIDIZING/RUSTING/ROTTING OFF IN LAYERS SOME FRAGMENTS OF RUST SCALE FALLING OFF MEASURE 1/8" IN THICKNESS I CONTACTED TOYOTA OF NORTH AMERICA KNOWING ABOUT THE RECALLS ON THE TOYOTA TACOMA MODEL TRUCKS WITH ALOT OF DETAILED PHOTOS THEY SAID BASICALLY TOO BAD. IVE KEPT THE UNDERCARRIAGE CLEAN EVEN TRIED USING COATINGS TO SLOW THE DETERIORATION DOWN THE TRUCK HAS 122,000 MILES ON IT AND WAS VERY WELL TAKEN CARE OF THE PROBLEM IS TOYOTAS POOR QUALITY STEEL USED AND IMPROPER FACTORY COATINGS I PURCHASED THE TRUCK IN 2014 AND I GLIMPSED UNDERNEATH THE DAY I BOUGHT IT AND THOUGHT THE FRAME LOOKED GOOD THEN A FEW MONTHS GO BY AND I GO TO DO A TUNE UP AND I START SEEING HUGE RUST SCALE FALLING ALL OVER UPON FURTHER INVESTIGATION NOTICED THE PROBLEM AND HOW BAD IT WAS AS WELL AS THE REASON I DIDNT NOTICE IT AT THE DEALER WAS THEY SPRAY PAINTED THE UNDERSIDE BLACK TO HIDE THE PROBLEM, I AM A MARINE CORPS VETERAN I SERVED 2007-2011 ACTIVE DUTY EVERY PENNY I HAD SAVED UP I USED TO BUY THIS TRUCK (MY FIRST BIG PURCHASE ALL IN CASH) IVE PUT THOUSANDS INTO THIS TRUCK ALREADY REPLACING SUSPENSION COMPONENTS AND MOUNTS AND ITS BECOMING A TOTAL LOSS I CANT SELL IT TO A PRIVATE PARTY KNOWING HOW DANGEROUS IT CAN BE IF THE WRONG PART FINALLY ROTS ALL THE WAY THRU AND I CANT AFFORD A NEW VEHICLE I CAN BARELY FIND WORK WITH THE ECONOMY AND PERSONAL STRUGGLES I HAVE RELATED TO MY SERVICE, I AM BEYOND UPSET AND I PRAY SOMEONE SOMEWHERE CAN HELP ME I KNOW MY TRUCK IS NOT THE ONLY TUNDRA WITH THIS MAJOR PROBLEM
Jun 23, 2017
ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES
1 complaint
VSC TRAC, VSC OFF, BRAKE, ABS LIGHTS... ALL ON, ALL AT ONCE.
Jun 19, 2017
AIR BAGS,VEHICLE SPEED CONTROL,UNKNOWN OR OTHER
1 complaint
HORN, AIRBAG AND CRUISE CONTROL LIGHT ON DO TO A BAD SPIRAL CABLE, THIS IS DANGEROUS. THIS IS A ONGOING PROBLEM WITH THIS VEHICLE.
Mar 13, 2016
ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM
1 complaint
SECONDARY INJECTION PUMP TRIGGER A LIMP MODE WHICH IS EXTREMELY DANGEROUS ON THE HIGHWAY. TOYOTA HAS EXTENDED THE WARRANTY ON ALL VEHICLE EXCEPT THE 2005, 2006, 2007 WHICH HAVE THE EXACT SAME AIR PUMPS INSTALLED. THIS REPAIR IS COSTING TOYOTA OWNERS IN EXCESS OF $3,000.00 WITH VEHICLES HAVING HAVING LESS THE 100K MILES. THIS IS OBVIOUSLY AN EMISSION ISSUE THAT TOYOTA SHOULD ADDRESS, THE U.S. HAS MADE VW RESPONSIBLE FOR THERE SHORTCOMINGS I THINK TOYOTA SHOULD BE HELD ACCOUNTABLE.
Jan 28, 2016
STEERING,AIR BAGS
1 complaint
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. WHILE DRIVING AT APPROXIMATELY 60 MPH, THE STEERING WHEEL SEIZED AND THE VEHICLE VEERED TO THE RIGHT. THE VEHICLE WENT OFF THE ROAD AND CRASHED INTO A TREE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS TAKEN TO THE CONTACT'S RESIDENCE WHERE IT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 86,000.
Jul 23, 2015
STEERING,SUSPENSION,SERVICE BRAKES, HYDRAULIC,STRUCTURE,TIRES
1 complaint
BOUGHT THIS VEHICLE USED IN 2010 AND IT HAD A LOT OF CORROSION UNDERNEATH THEN. CURRENTLY HAS 50 K MILES. MY BRAKES ARE SQUEALING DUE TO CORROSION PREVENTING THE CALIPERS FROM MOVING AND THE WHEEL WAS CORRODED TO THE HUB AND IT TOOK A LOT OF EFFORT TO REMOVE IT. THE STRUCTURAL MEMBERS AND ALL THE COMPONENTS HAVE LOOSE LAYERS OF RUST. THE EXHAUST HEAT SHIELDS FELL OFF. THE SPARE TIRE RESTRAINT SYSTEM LOOKS TOO WEAK SO I REMOVED THE SPARE. THE SPARE WHEEL IS SO CORRODED THAT THE BOLT HOLES ARE NO LONGER SMOOTH FOR THE LUGS TO BEAR AGAINST EVENLY. I AM CONCERNED THAT SOMETHING BAD WILL HAPPEN EVENTUALLY IF A WEAKENED CRITICAL PART WERE TO FAIL. I DOUBT THE UNDERCOATING TOYOTA IS OFFERING FOR 04 TO 06 TRUCKS CAN HELP MUCH AT THIS POINT. I DON'T WANT TO BE THE GUY WHO DROPS A FUEL TANK ON THE FREEWAY. *TR
Jul 30, 2014
POWER TRAIN,STRUCTURE
1 complaint
WAS TAKING IT TO HAVE ITS OIL CHANGED AND NOTICED A SMALL PUDDLE OF OIL UNDER THE REAR AXLE SETTING IN MY DRIVEWAY WHEN I TOOK IT BACK TO THE DEALER I ASK THEM TO CHECK THE REAR AXLE TO SEE WERE THE OIL WAS COMING FROM THEY TOLD ME THAT THE AXLE HOUSING HAD RUSTED THROUGH TOYOTA WONT COVER IT UNDER WARRANTY BECAUSE WARRANTY DOSNT COVER RUST AND IT IS GOING TO COST ME 3600.00 FOR THEM TO FIX IT . TO ME I THINK THIS IS A BUNCH OF BULL THIS TRUCK ONLY HAS 70192 MILES ON IT THERE IS NO WAY THIS SHOULD OF RUSTED OUT CAUSING A MAJOR SAFETY ISSUE IF I DIDN'T NOTICE THIS THE REAR AXLE COULD HAVE LOST ALL OF ITS OIL CAUSING A MAJOR MALFUNCTION THE AXLE COULD OF LOCKED UP BROKE THE AXLE CAUSING TO LOOSE CONTROLL CREATING A BAD ACCIDENT THEY SAY IT DOSNT COVER RUST BUT YET I GOT A RECALL NOTICE TO BRING IT IN TO HAVE THE FRAME INSPECTED FOR EXTREME RUST CORROSION. THIS DOSNT MAKE MUCH SENCE TO ME THEY WILL COVER THE RUSTY FRAME WHICH IS GREAT BUT THEY WONT COVER THE RUSTED OUT REAR AXLE THAT COULD CAUSE A CATASTROPHIC ACCIDENT AS WELL AS THE FRAME. *TR
Mar 31, 2014
STEERING,STRUCTURE
1 complaint
JANUARY 28TH (2014) I WAS INTO YORK'S TOYOTA FOR DIAGNOSIS OF A CHECK ENGINE LIGHT AND ROUGH IDLE PROBLEM. THE CLERK AT YORK'S TOYOTA ADVISED ME OF (2) RECALLS ON MY PICKUP TRUCK (BALL JOINT & SPRAY FRAME) AND SAID "WE WILL CALL YOU TO SCHEDULE WHEN TO HAVE THESE COMPLETED AT NO COST TO YOU". FEBRUARY 6TH WHILE DRIVING SOUTHBOUND ON INTERSTATE 95 AT THE POSTED SPEED OF 75MPH IN SHERMAN MAINE THE FRONT DRIVER'S SIDE OF MY 2005 TOYOTA TUNDRA BUCKLED. AFTER PULLING TO SIDE OF THE HIGHWAY I GOT OUT OF THE TRUCK AND SAW THE FRONT DRIVER'S SIDE BALL JOINT APPEARED TO HAVE SHEERED OFF CAUSING DAMAGE TO TIE ROD END, OTHER FRONT STEERING COMPONENTS AND SOME FRONT QUARTER PANEL DAMAGE. I CALLED THE MAINE STATE POLICE WHICH COMPLETED AN ACCIDENT REPORT. YORK'S HAS REFUSED TO PAY FOR THE REPAIRS TO THE VEHICLE. MY INSURANCE REFUSES TO PAY BECAUSE THE CAUSE OF THE ACCIDENT WAS A RECALLED PART. TOYOTA CORP IN CALIFORNIA HAS REFUSED TO PAY FOR ALL THE REPAIRS TO MY VEHICLE STATING THE BALL JOINT RECALL WAS FOR PREMATURE WEAR AND SINCE MY TRUCK HAS 150,000MILES IT DOESN'T QUALIFY. THIS IS COMPLETELY UNACCEPTABLE. A RECALL WAS ISSUED AND TOYOTA IS REFUSING TO FIX THE RECALLS AND THE DAMAGES. *TR
Feb 24, 2014
TIRES,WHEELS
1 complaint
DRIVING ON 81 N (MILE MARKER 160) IN PA AT 7:10 AM WHEN FRONT PASSENGER TIRE BLOWS OUT. THIS CAUSED ME TO SWERVE ACROSS BOTH LANES COME BACK HIT THE GUARD RAIL. TRUCK FLIPS OVER ONTO GUARD RAIL, SLIDES FOR A WAYS ON GUARD RAIL, THEN ROLLS OVER AS IT DESCENDS A HILL. THE BLOWOUT WAS IN MY LANE (GAUGE IN PAVEMENT) WITHOUT ANY OBJECT IN THE ROAD. TIRE LOST PRESSURE INSTANTANEOUSLY. BOTH TOW DRIVER & INSURANCE ADJUSTER POINTED OUT TIRE AS CAUSE OF ACCIDENT. THE TIRE WAS A MICHELIN LTX M/S2 WITH 33000 MILES ON IT, BUT IT HAD A 70000 MILE WARRANTY. SHAPE & DIRECTION OF TEAR IN TIRE IS IN THE OPPOSITE DIRECTION OF THE TIRE ROTATION, SO I TAKE THIS AS ADDITIONAL EVIDENCE THAT I DIDN'T RUN OVER AN OBJECT IN THE ROAD. *TR
Dec 15, 2013
STEERING,POWER TRAIN
1 complaint
GEAR SHIFT ON STEERING WHEEL COLUMN BECAME LOOSE AND IT BECAME VERY DIFFICULT TO PLACE TRUCK INTO PARK. IT STARTED GRADUALLY UNTIL THE PLAY IN THE SHIFTER WAS SO BAD THAT I COULD NO LONGER PUT IT INTO DRIVE, REVERSE OR NEUTRAL WITHOUT THE SHIFTER HANDLE HITTING THE WINDSHIELD WIPER HANDLE AND CAUSING THE WINDSHIELD WIPERS TO ACTIVATE AND SQUIRT CLEANER ONTO THE WINDSHIELD. I WAS CONCERNED THAT IT WAS GOING TO SLIP OUT OF GEAR OR INTO GEAR CAUSING INJURY OR DEATH, AND IT BECAME INCREASINGLY HARD TO PUT THE VEHICLE INTO PARK. I TOOK IT TO TOYOTA DEALER AND THEY REPLACED IT. I HAVE THE PART (A1 SHAFT SUB-ASSEMBLY / BD376 HOUSING, STEERING COLUMN) AND IT IS DEFECTIVE INFERIOR METAL PART BROKEN INTO TWO PIECES. *TR
Aug 18, 2013
STEERING,SERVICE BRAKES, HYDRAULIC,STRUCTURE
1 complaint
I HAVE BEEN TOLD MY TRUCK HAS EXCESSIVE RUST ON THE BRAKE LINE, FRONT BRAKE ROTORS AND POWER STEERING UNIT. THEY WILL AL NEED TO BE REPLACED. *TR
Aug 08, 2013
AIR BAGS,SEAT BELTS,TIRES
1 complaint
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE FRONT PASSENGER'S SIDE TIRE BLEW. AS A RESULT, THE CONTACT CRASHED INTO SEVERAL TREES. THE AIR BAGS FAILED TO DEPLOY AND THE SEAT BELT FAILED TO PROPERLY RESTRAIN THE CONTACT. THE CONTACT WAS TRANSPORTED TO THE HOSPITAL WHERE HE RECEIVED TREATMENT FOR SEVERAL INJURIES INCLUDING INJURIES TO THE NECK AND VERTEBRAE, A PARTIAL COLLAPSED LUNG, ROTATOR CUFF INJURIES TO THE RIGHT SHOULDER, AND TEARS TO THE BICEPS. A POLICE REPORT WAS FILED OF THE INCIDENT. THE VEHICLE WAS TOWED TO A BODY SHOP AND DECLARED DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 180,000. *TR
Jul 16, 2013
STEERING,WHEELS
1 complaint
I HAVE A 2005 TUNDRA 2WD TRD. I HAVE TO REPLACE THE STEERING RACK AND RECOMMENDED THAT I REPLACE BOTH REAR BEARINGS. WHEN LOOKING THE PROBLEMS ON THE INTERNET I HAVE DISCOVERED THAT THESE ISSUES ARE VERY COMMON FOR THE TUNDRA IN EARLIER PRODUCTION. THE STEERING RACK WAS MANUFACTURED WITH INFERIOR MATERIAL THAT HAS BEEN KNOWN TO WHERE OUT. THE SAME WITH THE REAR BEARINGS. IF THIS IS SUCH A COMMON PROBLEM WHY HASN'T A FORMAL INVESTIGATION EVER BEEN PERFORMED ON THESE TWO ELEMENTS OF THE TUNDRA. *TR
Mar 16, 2013
ELECTRICAL SYSTEM,EXTERIOR LIGHTING,STRUCTURE
1 complaint
DUE TO EXCESSIVE HEAT FROM BULBS OR MATERIAL TOO CLOSE TO HEAT SOURCE, HOLES WERE BURNED INTO A LENS CASING LOCATED ABOVE SLIDING GLASS WINDOW TO REAR OF DRIVER. *TR
Dec 02, 2012
EXTERIOR LIGHTING
1 complaint
THE CARGO/CENTER HIGH MOUNT BRAKE LIGHT HOUSING MELTED ABOVE EACH CARGO LAMP. THE PLASTIC HOUSING MELTED AND DRIPPED DOWN ON TO THE BULBS, CAUSING THE BULBS TO CRACK AND BECOME INOPERATIVE. THE FUSE PROTECTING THE CARGO LAMP CIRCUIT DID NOT BLOW, CAUSING CONCERN THAT THERE MAY BE A FIRE HAZARD. *TR
Jul 27, 2012
PARKING BRAKE
1 complaint
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED THAT THE EMERGENCY BRAKE WAS MALFUNCTIONING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO DIAGNOSED THAT THE FAILURE WAS DUE TO CORROSION AND THE PARKING BRAKE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 47,500 AND THE CURRENT MILEAGE WAS 47,972. THE VIN WAS NOT AVAILABLE.
Jul 28, 2011
AIR BAGS,SEAT BELTS
1 complaint
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED THAT THE VEHICLE WAS INVOLVED IN A CRASH. THE CONTACT STATED THAT THE SEAT BELTS FRACTURED DURING THE CRASH AND THE AIR BAGS DID NOT DEPLOY. THE DRIVER WAS REPORTED INJURED AND TRANSPORTED TO THE HOSPITAL WHERE HE REMAINED FOR FIVE DAYS TO TREAT INJURIES TO THE SHOULDER AND FACE. HE ALSO SUSTAINED A CONCUSSION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE IT WAS DEEMED AS DESTROYED. THE MECHANIC WAS UNABLE TO DIAGNOSE THE CAUSE OF THE SEAT BELT AND AIR BAGS FAILURES. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 87,000. UPDATED 3/1/12 *CN
May 19, 2011
STEERING,ENGINE AND ENGINE COOLING,STRUCTURE,SEATS
1 complaint
2005 TOYOTA TUNDRA. S10 APPROPRIATE HANDLING- LETTER TO THE SECRETARY FROM REGARDING TOYOTA PROBLEMS *TGW THE CONSUMER STATED THE OIL PAN WAS CRACKED ON THE SIDE, THE RACK AND PINION ASSEMBLY AND FAN HAD TO BE REPLACED. THE DRIVERS SIDE DOOR WAS LOOSE, THE SPRING WAS STICKING OUT OF THE SEAT COVER. THE CONSUMER HAS SINCE SOLD THE VEHICLE. *JB
Mar 02, 2011
ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL
1 complaint
UNINTENDED ACCELERATION OCCURRED WHEN PROCEEDING THROUGH AND INTERSECTION AT ABOUT 4:50 PM 01/04/2011. BRAKES WERE APPLIED BUT THE POWER OF THE TOYOTA TUNDA SR5 V8 ENGINE HAD ENOUGH POWER TO ACCELERATE UNINTENDED TO APPROXIMATELY 50 MPH EVEN THO THE BRAKES WERE APPLIED AS HAD HARD AS IT COULD BE APPLIED. THE TRUCK CENTERED AN OAK TREE IN THE BLVD APPROXIMATELY 150-200 FT FROM THE INTERSECTION. THE TRUCK WAS TOTALED BY MY INSURANCE COMPANY. ONLY THE DRIVER WAS IN THE TRUCK AND NO OTHER VEHICLES AT THE TIME OF THE INCIDENT. THE DRIVER SUFFERED A BROKEN LEFT ARM AT THE ELBOW WHICH REQUIRED SURGERY. *LN
Jan 23, 2011
VEHICLE SPEED CONTROL,EQUIPMENT,TRACTION CONTROL SYSTEM
1 complaint
I HAVE A TOYOTA TUNDRA 2005 THAT HAS HAD THE THROTTLE DRIVERS UPDATED. I HAVE HAD AT LEAST 6 INCIDENCES OF UNCONTROLLED ACCELERATION. THESE INCIDENCES OCCUR AT SLOW SPEED IN MUDDY SITUATIONS. DEPRESSING THE BRAKES TO THE FLOOR DOES NOT STOP THE VEHICLE AND I HAVE HAD SEVERAL NEAR MISSES. THIS OCCURS IN 2 WHEEL DRIVE AND I BELIEVE IT HAS TO DO WITH THE VSC AND SOFTWARE. THE ONLY WAY TO STOP THE THROTTLE OR UNWANTED MOMENTUM IS TO THROW THE VEHICLE INTO NEUTRAL. EVEN THIS DOES NOT IMMEDIATELY HELP. I RECOMMEND THE IGNITION KEY AS THE QUICKEST WAY TO STOP THIS. ADDITIONALLY, OUR COMPANY HAS A NEWER TUNDRA THAT IS GETTING FIXED UNDER THE RECALL. THIS TRUCK HAS EXPERIENCED SIMILAR SITUATIONS WITH OTHER EMPLOYEES DRIVING. SLOW SPEEDS IN 2 WHEEL DRIVE, IN MUDDY SITUATIONS THE TRUCK PUSHES YOU UNCONTROLLABLY. I WILL INVESTIGATE MORE ONCE THE TRUCK IS RETURNED WITH THE RECALL REPAIRS. THIS ALL IS RELATED TO THE VSC SYSTEM AND THE SOFTWARE. PLEASE HAVE AN INVESTIGATOR CALL ME. I BELIEVE THAT I CAN EASILY REPRODUCE THIS SITUATION IN THE VEHICLE. THESE VEHICLES ARE UNSAFE AND TOYOTA NEEDS TO ADDRESS THESE ISSUES. I DON'T BELIEVE THE CURRENT RECALL IS ADDRESSING THE ISSUE! *TR
Mar 10, 2010
FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM
1 complaint
SITTING IN TRAFFIC, THE ENGINE REVVED UP BY ITSELF ON MY 2005 TOYOTA TUNDRA SR5 V8. PROBLEM WAS ABATED BY TURNING ENGINE OFF AND RESTARTING. THIS PROBLEM RESULTED IN A MIL ERROR THAT SIDE B OF THE ENGINE WAS RUNNING LEAN. AFTER COMPLETING AN ANALYSIS OF THE PROBLEM, THE FINDINGS ARE THAT THE OXYGEN SENSORS ARE NOT RESPONDING TO SPECIFICATION. IT IS MY FIRM BELIEF THAT THE FIRMWARE ON THE ECM DOES NOT SELF CHECK FOR RUNAWAY CONDITIONS. *TR
Mar 09, 2010
POWER TRAIN,VEHICLE SPEED CONTROL
1 complaint
I BOUGHT A 2003 TOYOTA TUNDRA 4X4 AND SINCE I BOUGHT IT I FELT THAT WHEN I WAS AT A STOP LIGHT MY TRUCK ACCELERATED BY ITSELF MAKING A HUGE NOISE AT THE REAR END AXEL I TOOK MY TRUCK TO A TOYOTA DEALER AND THEY SAID IT THEY FIND NOTHING WRONG BUT THE PROBLEM CONTINUED FOR THE 2 YEARS I HAD THE TRUCK THEN I BOUGH A 2005 TUNDRA ALSO 4X4 AND IT HAS THE SAME PROBLEM DEALER DON'T DO ANYTHING TO SOLVE MY PROBLEM SOMETIMES IT FEELS LIKE IF SOMEONE HITS THE TRUCK FROM BEHIND LIKE A SUDDEN JUMP OR PUSH. *TR
Mar 05, 2010
ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE,VEHICLE SPEED CONTROL
1 complaint
LONG DELAY BETWEEN DEPRESSING "DRIVE-BY-WIRE" GAS PEDAL AND ENGINE RESPONDING. MY 2005 TOYOTA TUNDRA HAS AN ELECTRONIC GAS PEDAL. IT'S UNACCEPTABLE BEHAVIOR MAY EXPLAIN SOME OF THE CURRENT "SURGING" PEOPLE ARE SEEING IN OTHER TOYOTAS. THIS IS A 100% SOFTWARE PROBLEM (I AM A ELECTRONIC ENGINEER). DESCRIPTION: WHEN THE ENGINE IS AT IDLE, OR EVEN WORSE, WHEN YOU ARE DECELERATING AT IDLE POWER, AND YOU INCREASE THE THROTTLE POSITION OF THE GAS PEDAL, THERE IS A NEARLY 1-SECOND DELAY BEFORE THE ENGINE RESPONDS TO THE THROTTLE INPUT. IF THE DRIVER, NOT SENSING ANY RESPONSE TO THROTTLE, APPLIES MORE AND MORE THROTTLE DURING THAT ONE SECOND DELAY, WHEN THE ENGINE ELECTRONIC THROTTLE FINALLY DOES RESPOND IT WILL IMMEDIATELY GO TO THE HIGHEST THROTTLE SETTING THE DRIVER WAS SELECTING, CAUSING A HUGE LURCHING FORWARD ACTION OF THE VEHICLE. FOR EXAMPLE, IF THE DRIVER APPLIED THROTTLE IN THIS FASHION: 0SEC=5% THROTTLE; 0.25SEC=10% THROTTLE; 0.5 SEC=20% THROTTLE; 0.75SEC=35% THROTTLE; 1.0SEC=50% THROTTLE. THE ENGINE'S ELECTRONIC THROTTLE WILL RESPOND LIKE THIS: 0SEC=0% THROTTLE; 0.25SEC=0% THROTTLE; 0.5 SEC=0% THROTTLE; 0.75SEC=0% THROTTLE; 1.0SEC=50% THROTTLE. CAUSING THE HUGE LURCH AT 1.0 SECOND. THIS HAS BEEN ESPECIALLY DANGEROUS WHILE CHANGING LANES DURING STOP-AND-GO TRAFFIC IN THE SAN FRANCISCO BAY AREA. PLEASE NOTE THAT IF I AM RUNNING AT PARTIAL POWER/THROTTLE, THIS BEHAVIOR DOES NOT HAPPEN, AND THE GAS PEDAL RESPONSE IS PROPER. ONLY FROM IDLE OR DECELERATING. I HAVE COMPLAINED NUMEROUS TIMES TO MY TOYOTA DEALER, TO WHICH THE SERVICE MANAGER FINALLY REPLIED TO ME "YOU THINK THE TUNDRA IS BAD... YOU SHOULD TRY DRIVING THE SIENNA! IT'S WORSE!" SO APPARENTLY THE FOLKS AT TOYOTA KNOW ABOUT THIS AND THINK IT'S FUNNY. I CAN DEMONSTRATE THIS DEFECT AT ANY TIME. I HAVE CHANGED MY DRIVING STYLE TO PROTECT ME FROM THE VEHICLE'S DEFECT. *TR
Mar 03, 2010
SERVICE BRAKES, HYDRAULIC,ELECTRICAL SYSTEM
1 complaint
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED WHILE DRIVING AT 25 MPH THE ABS LIGHT WOULD FLASH ON THE DASH BOARD INDICATING THAT THE BRAKES NEED TO BE SERVICED. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC TO HAVE THE BRAKES SERVICED AND THE LOCAL MECHANIC COULD NOT FIND A ISSUE WITH THE BRAKES. ALSO THE CONTACT STATED THAT THE AIR FLOW BUTTON THAT CONTROLS THE AIR INSIDE THE VEHICLE IS MALFUNCTIONING. THE CONTACT FEELS THIS VEHICLE HAS A SERIOUS ELECTRICAL ISSUE AND NEEDS TO LOOKED AT BY THE MANUFACTURER. THE FAILURE MILEAGE 6,000.
Feb 16, 2010
VEHICLE SPEED CONTROL,EQUIPMENT
1 complaint
2005 TOYOTA TUNDRA -- 3 TIMES IT SPED UP ON ITS OWN. EITHER FLOORMAT AND/OR ACCELERATOR. THIRD TIME THERE WAS A CRASH, INTO OUR RETAINING WALL IN OUR DRIVEWAY. I TRIED TO GET PEOPLE TO PAY ATTENTION, CONTACTED CUSTOMER SERVICE, ETC., AT TOYOTA, NO ONE BELIEVED IT. ALSO INSURANCE COMPANY SAID IT WAS DRIVER'S FAULT. *TR
Feb 02, 2010
LATCHES/LOCKS/LINKAGES
1 complaint
THE DRIVER DOOR LATCH NOT ENGAGING, DOOR WOULD NOT STAY CLOSED. TOOK TO DEALER SHIP AND THE ENTIRE MODULE HAD TO BE REPLACED. *TR
Nov 26, 2008
EQUIPMENT
1 complaint
TRUCK ACCELERATED DUE TO FLOOR MAT SLIPPAGE. *TR
Dec 01, 2007
SUSPENSION,SERVICE BRAKES, HYDRAULIC
1 complaint
I HAVE A 2005 TOYOTA TUNDRA WITH 24,000 MILES AND HAVE EXPERIENCED 3 ISSUES. 1 BRAKE FAILURE ON OFF RAMP. 1/2/07 LOWER BALL JOINT REPLACEMENT- RECALL BY TOYOTA. 7/9/07 LEFT REAR WHEEL BEARING REPLACED 8 /14/ 07 ALL OF THESE PROBLEMS WERE ADDRESSED BY TOYOTA OF TEMECULA. TOYOTA HAS INCREASED THE BRAKE SIZE ON NEW TUNDRA TRUCKS. WHY? THESE ARE QUALITY AND SAFETY ISSUES AND I AM WONDERING WHEN THE NEXT PROBLEM WILL HAPPEN.*JB UPDATED 09/26/07 *TR
Sep 07, 2007
SUSPENSION,EQUIPMENT ADAPTIVE/MOBILITY
1 complaint
MY 2005 TOYOTA TUNDRA WAS IN FOR SERVICE THE MECHANIC SAID THERE WAS A RECALL ON THIS TRUCK SO I AGREED TO LET TOYOTA REPLACE MY BALL JOINTS (RECALL NO: 70B) AFTER THE REPLACEMENT WAS DONE THE VEHICLE STEERING BEGAN TO FADE TO THE LEFT AND THEN TO THE RIGHT I RETURNED TO THE DEALER AND HE SAID THAT IT NEEDED A FEW ADJUSTMENTS AFTER DRIVING IT AGAIN THE PROBLEM STILL EXISTED AFTER DRIVING THE TRUCK FOR A FEW MONTHS I FOUND THAT MY TIRES WERE WEARING DUE TO FEATHERING TO THE RIGHT AND LEFT ALSO THE VEHICLE BECAME HARD TO HOLD STRAIGHT IN LINE WHILE DRIVING WHEN I WOULD RUN OVER A SMALL DEPRESSION IN THE ROAD THE STEERING WOULD PULL ME IN TO ONCOMING TRAFFIC. I DROVE THE TRUCK BACK TO THE DEALER 08/06/2007 THEY DID A SERIES OF TEST BUT NOTHING WORKED. FINAL WORDS YOU JUST HAVE TO LIVE WITH IT. I CONTACTED TOYOTA CONSUMER COMPLAINT LINE AND LOW AND BEHOLD A RECORDING CAME ON ADDRESSING SYMPTOMS WITH THE TUNDRA THE DEAL IS I DID NOT HAVE THIS PROBLEM AS THEY DESCRIBED IT ON THE RECORDING UNTIL AFTER THEY REPLACED THE BALL JOINTS. *JB
Aug 15, 2007
SUSPENSION,TIRES
1 complaint
TL*THE CONTACT OWNS A 2005 TOYOTA TUNDRA. WHILE DRIVING 65 MPH, THE VEHICLE SHAKES AND PULLS TO THE RIGHT SIDE. THE CONTACT HAS TAKEN THE VEHICLE TO THE DEALER THREE TIMES FOR AN ALIGNMENT. THE FAILURE PERSISTS AND THE DEALER WAS UNABLE TO DETERMINE THE CAUSE. THE LOWER BALL JOINT WAS ALSO REPLACED. THE POWERTRAIN AND MILEAGE INFORMATION WERE UNKNOWN. THE CONSUMER STATED THE TRUCK IS NOT RUNNING RIGHT, HE FURTHER STATED TOOK TO THE DEALER AND THEY CHECK THE TIRE PRESSURE AND DO AN ALIGNMENT BUT IT DOES NOT REMEDY THE PROBLEM. THE CONSUMER STATED REQUESTING DEALER TO FIND OUT WHAT IS WRONG WITH THE TRUCK. UPDATED 08/01/07 *TR
Jun 27, 2007
PARKING BRAKE,VEHICLE SPEED CONTROL
1 complaint
PARKING BRAKE ENGAGED PARTIALLY. ALSO THE ENGINE IDLED TOO FAST. THIS COMBINATION LEAD TO THE VEHICLE TO START MOVING UNEXPECTEDLY. AS A RESULT MY WIFE INJURERED HER FOOT AND DAMAGE TO THE VEHICLE WAS SUSTAINED. THIS COULD HAVE EASILY RESULTED IN A FATALITY.*AK
May 16, 2007
SERVICE BRAKES, HYDRAULIC,SERVICE BRAKES, AIR
1 complaint
BRAKES FEEL INCONSISTENT. LAST MONTH ABS LIGHT CAME ON AND STAYED ON WHOLE DAY. NEXT DAY LIGHT WENT OFF. INTERNET SEARCH SAYS MANY 2005 TUNDRA OWNERS ARE EXPERIENCING REAR BRAKE CALIPER DEFECT. THIS CAUSES FRONT BRAKES TO PREMATURELY WEAR-OUT.
Jan 19, 2007
CHILD SEAT
1 complaint
TL*- THE CONTACT STATED THAT ON 01/09/07 THE NEWS REPORTED THAT EVENFLO DISCOVERY SAFETY SEAT WAS NOT SAFE. THE NEWS REPORT STATED THAT THE SEAT DISLODGED FROM THE BASE, TWISTED AND FELL OFF. THE NEWS STATED THAT THE SAFETY SEAT DID'T PASS SAFETY STANDARDS. THE CONTACT STATED THAT SHE CALLED EVENFLO ,AND WAS TOLD THAT THE SEAT HAD NOT BEEN RECALLED. THE MANUFACTURER TOLD THE CONTACT THAT THE SEAT WAS SAFE, AND THEY WILL NOT REIMBURSE HER FOR THE SEAT. *AK
Jan 09, 2007
STEERING,SUSPENSION,ENGINE AND ENGINE COOLING
1 complaint
2005 TOYOTA TUNDRA QUAD CAB. FRONT END ALIGNMENT PROBLEMS, EXTREME PULLING TO THE LEFT AND RIGHT, CONSISTENT RATTLING IN THE FRONT END. CONTROL ISSUES AT 5 MPH, EXTREME SHIMMERING OVER 65 MPH. RECOMMENDED PARTS BY SERVICE DEPARTMENT KNUCKLE SUB ASSEMBLY, BEARINGS, RING HOLE, SEALS. VEHICLE LOSES POWER, AND STEERING CONTROL, CAUSED ACCIDENT. MANUFACTURER REFUSES TO HONOR WARRANTY AND REPAIR VEHICLE. PROBLEMS BEGAN AT 2000 MILES, TAKEN IN AT 5009 MILES FOR SERVICE AND REPORTED PROBLEM, 4 ATTEMPTS AT REPAIR WITH NO SUCCESS. *NM
Feb 07, 2006
STEERING,TIRES
1 complaint
I HAD MY 2005 TUNDRA BED LOADED TO THE MAXIMUM ADVERTISED WEIGHT CAPACITY. ONCE I ENTERED THE HWY AND REACHED A SPEED OF 45 THE VEHICLE WENT OUT OF CONTROL. I HAVE BEEN DRIVING FOR MANY YEARS AND HAVE NEVER EXPERIENCED A LOSS OF CONTROL LIKE THIS. THE VEHICLE LEFT THE ROAD AND FLIPPED UPSIDE DOWN. THE CAB HELD UP GREAT AND EVERYONE WAS WEARING THEIR SEATBELT THEREFOR THERE WERE NOT SIGNIFIGANT INJURIES. ATLEAST ONE OF THE TIRES WERE OFF THE RIM BUT I'M NOT SURE IF THIS WAS A RESULT OF THE ACCIDENT OR A CAUSE.
Jul 22, 2005
Where to Find VIN for Problems Check
To check for problems and complaints on your 2005 TOYOTA Tundra, you'll need the VIN number. Find your VIN in one of these 4 common locations.
Understanding VIN Structure for Problem Reports
Each character in your 2005 TOYOTA Tundra 17-digit VIN helps identify specific complaints and problems affecting your vehicle model.
How to Check 2005 TOYOTA Tundra Problems in 3 Steps
1
Locate Your VIN
Find the 17-character VIN on your 2005 TOYOTA Tundra dashboard (visible through windshield), door jamb, engine bay, or vehicle documents.
2
Review by Component
Browse owner-reported complaints organized by vehicle component (engine, transmission, brakes, electrical) to identify common issues and problem patterns for this model year.
3
Check Safety Issues
Review crash and fire incidents for each component to assess safety concerns. Contact your TOYOTA dealer or report problems to NHTSA at SaferCar.gov.
Frequently Asked Questions
How many problems does the 2005 TOYOTA Tundra have?
The 2005 TOYOTA Tundra currently has 374 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.
What are the most common problems with 2005 TOYOTA Tundra?
The most common problems reported for the 2005 TOYOTA Tundra are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.
Where does this 2005 TOYOTA Tundra problem data come from?
All problem and complaint data for the 2005 TOYOTA Tundra comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.
How do I report problems with my 2005 TOYOTA Tundra?
You can report safety problems with your 2005 TOYOTA Tundra directly to NHTSA at SaferCar.gov or call 1-888-327-4236. Your complaint helps identify patterns and may lead to recalls or investigations.
Where can I find my VIN to check problems?
Your 2005 TOYOTA Tundra VIN is located in 4 places: (1) Dashboard near windshield on driver's side, (2) Driver's door jamb sticker, (3) Engine bay, (4) Vehicle registration and insurance documents.
Is the 2005 TOYOTA Tundra reliable?
Reliability can be assessed by reviewing the number and severity of owner complaints for the 2005 TOYOTA Tundra. Check complaints by component, crash reports, and fire incidents above to evaluate potential issues and problem patterns.
Other Years - TOYOTA Tundra Problems
2025
2024
2023
2022
2021
2020
2019
2018
2017
2016
2015
2014
2013
2012
2011
2010
2009
2008
2007
2006
2004
2003
2002
2001
2000
Other TOYOTA Models
Similar Brands
ST
3,555 models
RS
3,484 models
NC
2,822 models
ND
2,385 models
Z
1,951 models
MOTO
1,583 models
NU
1,189 models
RC
1,122 models