2016 TOYOTA Tundra Problems

VIN Decoder

Premium Report

114

Complaints Reported

Radar Detector GPS Tracker OBD2 Scanner Car Refrigerator Jump Starter Dash Cam

As an Amazon Associate, ForCar.org earns from qualifying purchases.

Complaints by Component

SERVICE BRAKES

23 complaints

The trailer brake controller went out. It does not supply electronic braking and the truck no longer recognizes the controller on the dashboard. Multiple on line chats and forums, along with my trailer provider, show awareness of this defect. Online individuals learned of the issue during emergency stopping. This appears to be known and wide spread.

Feb 20, 2025

The integrated brake controller does not apply enough power to the trailer brakes.

Jul 03, 2023

Bought a used 2016 Tundra, unaware of the massive problem they have with their intergrated brake controller, i feel they need to do something about this or reimburse the buyer for buying a aftermarket one to replace the factory unit. Its a very unsafe problem when pulling a trailer, I love the truck otherwise but this issue needs fixed.

Feb 27, 2022

BRAKE CONTROLLER DOESN'T WORK AS IT DESIGNED.

Feb 11, 2020

REAL SAMPLE THE BRAKE CONTROLLER DOESN'T WORK NO MATTER IF YOU SET IT UP TO 9.5 OR 10 DOESN'T DO ANY BRAKE APPLIED.

Oct 29, 2018

+ 18 more complaints for this component

STRUCTURE

16 complaints

Peeling paint. White paint is separating from primer on hood, and adjacent to windshield on a pillars and the leading edge if the roof.

Nov 05, 2024

The contact owns a 2016 Toyota Tundra. The contact stated that while driving at an undisclosed speed, the vehicle ran off the road during a thunderstorm, causing the driver's and passenger's side curtain air bags to deploy. The vehicle was towed to the dealer, who informed the contact that the headliner needed to be replaced; however, the part to complete the repair was not available. The manufacturer was made aware of the failure and confirmed that parts were not yet available. The failure mileage was approximately 99,000.

Sep 07, 2023

TL* THE CONTACT OWNS A 2016 TOYOTA TUNDRA. WHILE THE CONTACT WAS SERVICING THE VEHICLE, THE BUMPER DETACHED WHEN A FRIEND STEPPED ON THE BUMPER. PRIOR TO THE FAILURE, THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 17V051000 (STRUCTURE). THE CONTACT DROVE TO AUTONATION TOYOTA SOUTH AUSTIN (4800 S IH 35 FRONTAGE RD, AUSTIN, TX 78745, 512 518-6900) AND WAS INFORMED THAT SINCE THE VEHICLE WAS PREVIOUSLY INVOLVED IN A CRASH, THEY WOULD NOT REPLACE THE BUMPER. THE MANUFACTURER WAS CONTACTED AND SIDED WITH THE DEALER; HOWEVER, THEY FELT THE RECALL SHOULD STILL BE REMEDIED. THE MANUFACTURER REFERRED THE CONTACT TO SAN MARCOS TOYOTA (5101 I-35, SAN MARCOS, TX 78666, 512-392-1999) WHERE THEY POINTED OUT DAMAGE TO THE SIDE AND REAR OF THE VEHICLE AND ALSO REFUSED TO SERVICE THE RECALL. THE CONTACT CALLED THE MANUFACTURER BACK AND FILED A COMPLAINT REGARDING THE REFUSAL OF SERVICE. THE CONTACT DROVE TO UNIVERSAL TOYOTA (12102 I-35, SAN ANTONIO, TX 78233, 726-444-6959) WHERE THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 76,000. THE VIN WAS UNKNOWN.

Sep 10, 2019

REAR BUMPER RECALL. AS OUTLINED IN TOYOTA TUNDRA REAR BUMPER RECALL. THE REINFORCEMENT CRACKED AND SOMEONE STEPPED ON THE BUMPER COVER AND NOW THE DEALER AND TOYOTA WILL NOT PREFORMED THE NEEDED REPAIRS STATING THE THE VEHICLE WAS IN A ACCIDENT AND SHOULD BE REPAIRED UNDER INSURANCE.

Jun 29, 2018

THERE IS A KNOWN RECALL ON THE REAR BUMPER BRACKETS. FOR NEARLY 6 MONTHS, THE DEALERS IN SOUTH FLORIDA (ESP TOYOTA OF NORTH MIAMI) HAVE BEEN UNABLE TO ASSIST IN REMEDY OF THIS ISSUE AS THEY DO NOT HAVE THE PARTS IN STOCK.

Jan 07, 2018

+ 11 more complaints for this component

ELECTRICAL SYSTEM

12 complaints

Odometer Fraud. The contact purchased a 2016 Toyota Tundra. The contact stated while going through prior service paperwork found in the vehicle, he discovered that there was a mileage discrepancy. The vehicle was a private sale. The contact also stated that the vehicle was once sold at a private auction. At the time of purchase, the vehicle mileage was 158,000; however, upon discovery of the service paperwork, the contact discovered that the vehicle mileage was once 250,000.

May 07, 2025

Seat heater stopped working. Turns out there is a burnt connector leading to part number 87501-0C020, which appears to be a seat heater amp. One pin of the connector is completely melted. I've purchased this truck brand new from Toyota. Nobody has ever touched this part. Scared that it could have caught fire.

Sep 06, 2023

THE FRONT DRIVER AND FRONT PASSENGER DOOR LOCK INTERMITTENTLY DO NOT WORK. THERE ARE NO SPECIFIC PARTS OF THE DAY, TIME, WEATHER CONDITIONS. IT WILL WORK FINE AND THEN EITHER ONE FAILS OR THE OTHER, OR BOTH. THEN ITS STARTS TO WORK AGAIN WITHOUT ANY ISSUES. THIS HAS BEEN GOING ON FOR AT LEAST 12-18 MONTHS.

Mar 01, 2021

ON MY 2016 TOYOTA TUNDRA PLATINUM EDITION, AT NIGHT WITH HEADLIGHTS IN "AUTO" POSITION, WHEN I USE TURN SIGNAL, THE HEADLIGHTS, TAILLIGHTS AND DASH LIGHTS ALL OCCASIONALLY TURN OFF. ONCE TURN SIGNAL SHUTS OFF, LIGHTS COME BACK ON . IT TYPICALLY HAPPENS AT NIGHT WHEN IT'S COLD OUT. THEM IS INTERMITTENT, THIS IS SO SCARY! I WAS GOING DOWN THE FREEWAY AT 80 MPH AT NIGHT AND MY TRUCK (FULL OF MY FAMILY) JUST DISAPPEARED WHEN I CHANGED LANES. I HAVE TAKEN MY TRUCK IN 3 TIMES NOW AND TOYOTA CAN'T REPLICATE SO THEY SAYS THEY CAN'T FIX IT. PLEASE HELP! BEFORE SOMEONE GETS HURT.

Jan 08, 2020

THE TRAILER BRAKES WILL NOT OPERATE CORRECTLY. THE TRAILER BRAKES WILL NOT LOCK UP EVEN WHEN SET ON 10. VERY DANGEROUS WHEN HAULING ANY TRAILER WITH BREAKS. I HAVE PUT MY OTHER TRUCK TO THE TRAILER AND IT OPERATES GREAT. IT IS ABSOLUTELY THE BREAK CONTROL FROM THE FACTORY NOT THE TRAILER

Aug 07, 2018

+ 7 more complaints for this component

EXTERIOR LIGHTING

9 complaints

My right front headlamp is getting moisture inside the headlamp assembly. It can be inspected any time. Chance that headlamp will not work. Did not take to a dealer.

May 24, 2025

HEADLIGHTS IN THE ON OR AUTO POSITION RANDOMLY GO OUT WHEN BLINKER RETURNS TO NEUTRAL POSITION AFTER BEING ENGAGED. THIS HAS HAPPENED WHILE IN MOTION AT LOW AND HIGHSPEEDS ON CITY STREETS AND HIGHWAYS AND COMING OUT OF A COMPLETED STOP. CANNOT DETERMINE IF THIS IS A SHORT IN WIRING HARNESS OR IF TRIGGERED BY FAULTY COMPONENT.

Feb 14, 2021

HEADLIGHTS, TAILLIGHTS, AND DASHLIGHTS ALL GO OFF WHEN USING THE TURN SIGNAL. THIS HAS HAPPENED HALF A DOZEN TIMES AT NIGHT WHEN THE TEMPERATURE IS IN THE 30'S, BOTH WHEN TURNING ON NARROW UNLIT RURAL ROADS, AND ON THE INTERSTATE AT 75MPH WHEN CHANGING LANES. IT IS A COMMON PROBLEM WITH THE 1794 EDITION OF THE TUNDRA WITH THE AUTOMATIC HEADLIGHTS. YOU CAN FIND DOZENS OF OTHER TUNDRA OWNERS WHO HAVE EXPERIENCED THIS PROBLEM, INCLUDING A VIDEO ON THE TUNDRA.COM WEBSITE. SEE LINK BELOW: HTTPS://WWW.TUNDRAS.COM/THREADS/AUTO-HEADLIGHTS-SHUT-OFF-WITH-TURN-SIGNAL.22968/ THIS IS EXACTLY WHAT HAS HAPPEND TO ME, AND IT IS SCARY DANGEROUS. I REPORTED THIS TO NHTSA BACK IN DECEMBER, AND TOYOTA HAS YET TO DO ANYTHING ABOUT IT. THEY HAVE NOT EVEN ISSUED A SERVICE BULLETIN. PLEASE GET THEM TO FIX THIS! EVEN MY TOYOTA SERVICE AGREEMENT WON'T FIX MY TUNDRA, BECAUSE THE DEALER CAN'T REPLICATE THE PROBLEM (IT'S NOT COLD, AND THEY CLOSE AT 6 WHEN IT'S NOT DARK!), AND THERE IS NO SERVICE BULLETIN OR ANYTHING FROM TOYOTA ACKNOWLEDGING THIS IS EVEN A PROBLEM. I'M BEGGING YOU, AT LEAST GET TOYOTA TO ACKNOWLEDGE THERE IS A PROBEM AND FIGURE OUT HOW TO FIX IT!!

Jun 29, 2020

THE HEADLIGHTS AND INTERIOR DASH LIGHTS RANDOMLY TURN OFF WHEN USING THE BLINKER. I HAVE OWNED THIS TRUCK FOR 3 MONTHS NOW AND IT HAS HAPPENED ON FOUR DIFFERENT OCCASIONS. I CANNOT REPLICATE THIS ISSUE ON MY OWN.

Feb 26, 2020

WHILE DRIVING AT NIGHT, THE ACTIVATION OF TURN SIGNAL INTERMITTENTLY SHUTS OFF HEADLIGHTS. TO RE-ENERGIZE HEADLIGHTS I HAVE TO MANUALLY SWITCH THE HEADLIGHT SWITCH FROM AUTO TO ON. THIS IS VERY DISTURBING AND DANGEROUS WHILE DRIVING AT NIGHT IN RURAL AREAS. I AM HOPING SOMEONE ADDRESSES THIS WITH TOYOTA, SINCE IF THEY CAN'T REPLICATE THE ISSUE THEY SEND YOU HOME!

Feb 02, 2020

+ 4 more complaints for this component

ELECTRICAL SYSTEM,EXTERIOR LIGHTING

5 complaints

MY HEADLIGHTS SHUT OFF WHEN USING MY TURN SIGNAL

Dec 07, 2020

MY 2016 TOYOTA TUNDRA 1794 CREWMAX, DURING WINTER MONTHS IN MIDWEST - THE HEADLIGHTS AND AND INTERNAL INSTRUMENTATION WILL TURN OFF WHEN TURNING LEFT OR RIGHT WITH TURN SIGNAL ENGAGED. THE AUTOMATIC LIGHTS ARE ENGAGED ON COLUMN STALK AND THE ISSUE OCCURS AT NIGHT. THE VEHICLE IS IN MOTION

Nov 28, 2020

HEADLIGHTS TURN OFF INTERMITTENTLY WHEN THE LEFT TURN SIGNAL IS USED AND THE HEADLIGHTS SWITCH IS IN AUTO MORE. DEALERSHIP CAN'T/WON'T REPLICATE THE ISSUE SO THEY WILL NOT TROUBLESHOOT FURTHER. THIS IS A PROBLEM THAT A LOT OF PLATINUM AND 1794 EDITION TOYOTA TUNDRAS ARE HAVING AND IT IS BEING IGNORED BY TOYOTA; HTTPS://WWW.TUNDRAS.COM/THREADS/AUTO-HEADLIGHTS-SHUT-OFF-WITH-TURN-SIGNAL.22968/ HTTPS://WWW.YOUTUBE.COM/WATCH?V=2TZRPLQ9WP4 I'VE HAD IT INTO THE DEALERSHIP TO CHECK AND THEY SAY THERE IS NOTHING THEY CAN DO. PICKUP ONLY HAS ABOUT 26K MILES ON IT. FIRST TIME IT HAPPENED WAS ON A FREEWAY CLOVERLEAF IN THE RAIN AND LUCKILY THERE WERE STREET LIGHTS BECAUSE I WAS IN THE MIDDLE OF A MERGE. OTHER TIMES IT HAS BEEN SIGNALING TO TURN LEFT AND ENTERING THE CENTER TURN LANE ON MULTI-LANE ROADS. ALWAYS HAPPENS WHILE IT IS DARK OUTSIDE BECAUSE THAT'S WHEN THE HEADLIGHTS ARE IN AUTO WHICH MAKES IT MORE DANGEROUS.

Apr 24, 2020

ON MY 2016 TOYOTA TUNDRA 1794 EDITION, WITH HEADLIGHTS IN "AUTO" POSITION, WHEN I USE TURN SIGNAL, THE HEADLIGHTS, TAILLIGHTS AND DASH LIGHTS ALL OCCASIONALLY TURN OFF. ONCE TURN SIGNAL SHUTS OFF, LIGHTS COME BACK ON . IT TYPICALLY HAPPENS AT NIGHT WHEN IT'S COLD OUT. IT HAS NOW HAPPENED PROBABLY HALF A DOZEN TIMES IN THE LAST SIX MONTHS. WHILE PROBLEM IS INTERMITTENT, IT'S VERY SCARY, AS I'M DRIVING BLIND ON A RURAL ROAD UNTIL THE LIGHT COME BACK ON. ON THE TUNDRAS.COM OWNERS WEBSITE, THIS APPEARS TO BE A COMMON ISSUE. HELP! BEFORE SOMEONE GETS HURT.

Dec 22, 2019

ALL LIGHTS (HEADLAMPS AND TAIL LAMPS AND INSTRUMENT PANEL) TURN OFF WHEN USING TURN SIGNAL. THIS TYPICALLY HAPPENS WHEN CHANGING LANES AT HIGHWAY SPEED. I AM NOT THE ONLY ONE EXPERIENCING THIS PROBLEM. SEEMS TO OCCUR IN 2015-2017 TOYOTA TUNDRAS (1794 & PLATINUM EDITIONS). SEE THREAD. HTTPS://WWW.TUNDRAS.COM/THREADS/AUTO-HEADLIGHTS-SHUT-OFF-WITH-TURN-SIGNAL.22968/PAGE-3

Nov 10, 2019

UNKNOWN OR OTHER

5 complaints

TODAY 01/31/2019 I WAS DRIVING MY 2016 TOYOTA TUNDRA 1794 CREW MAX TRUCK ON THE FREEWAY IN OAKLAND, CA AROUND 1:30 PM. I HAD BEEN DRIVING WITH THE REAR (FACING) WINDOW DOWN APPROXIMATELY 8 " I WAS IN THE PROCESS OF CLOSING THE REAR ELECTRIC WINDOW AND JUST AS IT CLOSED I DROVE OVER A STEEL TRENCH PLATE THAT HAD BEEN PLACED ON THE FREEWAY BY CAL TRANS ALL 3 THINGS HAPPENED AT ONCE, THE WINDOW CLOSED, I DROVE OVER THE PLATE AND THE SUNROOF EXPLODED OUTWARD WITH A SHOTGUN LIKE BANG, I HAD THE SUN SHADE CLOSED SO NO GLASS FELL ON ME. I BELIEVE THAT THE CHANGE IN CABIN AIR PRESSURE COUPLED WITH THE IMPACT OF THE TRENCH PLATE WAS ALL IT TOOK TO CAUSE THIS FLAWED SUNROOF TO EXPLODE UNDER NORMAL OPERATING CONDITIONS. THE WEATHER WAS SLIGHTLY OVERCAST AND APPROXIMATELY 64 DEGREES AT THE TIME. I HAVE PHOTOS BUT CAN NOT UPLOAD THEM AT THIS TIME. THE VEHICLE IS NOW AT THE LOCAL TOYOTA DEALERSHIP.

Jan 31, 2019

IBC DOES NOT FUNCTION

Jul 13, 2017

ABOUT 3 MONTHS AFTER PURCHASING MY VEHICLE, I'VE NOTICED THE FRONT SENSORS (INTERMITTENTLY) KEEP GOING OFF. THIS HAPPENS ONCE OR TWICE EVERY OTHER WEEK. TAKEN TO DEALERSHIP, AT THIS TIME CAN'T DETERMINE WHAT'S CAUSING THE PROBLEM. ALSO, THE RADIO SHUTS OFF FOR SEVERAL MINUTES, THEN COMES BACK ON.

May 25, 2017

INTEGRATED TRAILER BRAKE CONTROLLER NOT WORKING. SET AT ITS HIGHEST RATING IT STILL DID NOT WORK. CHECKED TRAILER BRAKES WITH ANOTHER TRUCK AND THEY WORK. APPLIED THE BRAKES WITH THE MANUAL ACTIVATOR AND NO BRAKES. CAME CLOSE TO HAVING AN ACCIDENT. WILL BE MEETING WITH DEALER ON THIS ISSUE. RESEARCH ON THE INTERNET SHOWS THAT THIS MIGHT BE A COMMON PROBLEM

Feb 27, 2017

FACTORY INTEGRATED BRAKE CONTROLLER DOES NOT WORK EFFICIENTLY. WITH THE IBC GAIN UP TO 10, THE TRAILER BRAKES ARE NOT ACTIVATED ENOUGH TO SLOW THE VEHICLE IN A NORMAL OR EMERGENCY SITUATION. THE MANUAL OVERRIDE SLIDE BAR BARELY ENGAGES THE TRAILER BRAKES, IT WILL NOT LOCK THE TRAILER BRAKES AS DESIGNED. VEHICLE BRAKES BEGIN TO GET TO HOT TO SLOW BOTH THE TRUCK AND TRAILER COMING DOWN HILLS, EXTREMELY DANGEROUS!

Jun 10, 2016

STEERING

4 complaints

The power steering went out during routine around-town driving. One moment it was steering fine, the next moment it became extremely difficult and sluggish. There were no warning lights or warning of any sort until the steering wheel started jerking unevenly as I tried to turn. I was able to get control of the vehicle and pull it to the side of the road. There was no difference in the engine noise, and I couldn't see any noticeable fluid leak. I was able to drive the vehicle home, make an appointment with the Toyota dealer, and get the vehicle to the dealership for inspection. The dealership told me after inspection, that the rack and pinion steering was binding internally, and that there was seepage from the right boot. Initially, they told me that the pump should be fine. I authorized them to replace the rack and pinion steering. After which, they told me that the problem seemed to still persist some, and that the pump would have to be replaced also. My total bill came to $3,200, which seemed not unfair. But this whole issue seemed like something that should be noticed as part of a recall. I found the NHTSA recall number. 21V-920, and my truck seemed to match exactly the symptoms spelled out is this recall , but Toyota refused to acknowledge it. My VIN number did not fall within the specified VIN for this recall. I've driven several Toyotas, including another Tundra, a Tacoma, 2 Highlanders and a Sienna, and have been pleased with each vehicle. This Tundra is 10 years old with 95,000 miles, and I've only done expected maintenance and a couple of occasional minor repairs. Those being: - Having the brakes resurfaced - Changing out the alternator In the end, it wasn't a devastating amount of money, but it was an issue that I felt Toyota should have taken care of. I did reach out to them, but because I had already paid for the repairs on the vehicle I needed to drive for work, they refused to talk to me any further. I have the estimate and final bill.

Dec 16, 2025

I was stopped at a turn light to merge left onto freeway and the truck steering went out when trying to turn, it led me into oncoming traffic that was just coming to a stop light, I was able to crank my wheel with all my strength to get to the side of the uphill freeway merge ramp. There were no warning signs. It was so scary and thank goodness I hadn't merged onto the freeway. The component that failed was the power steering assembly, rack and pinion with inner and outer tie rods. I don't believe the parts will be available for inspection since the truck was towed to repair shop. Overall, I was lucky to be alive. My safety was put at risk being unable to properly steer, if I had been going any faster, or even on the freeway there would be no way to control the vehicle. Initially, I was put into oncoming traffic that was coming to a stop. It put myself and everyone around me in danger. The problem has been confirmed by an independent repair shop that truck was towed to. They immediately saw the problem and took several days to fix. Even questioned what I was doing at the time of this event, because something like this just doesn't typically happen. It concerned them so much, that United Wheels and Tires suggested I reach out to Toyota. The vehicle has not been inspected by anyone but the dealer and the tow truck services. Insurance was notified of situation and services dispatched, since the truck was not drivable. There were NO warming lamps, messages or anything on truck. Truck is in perfect condition and drove only on roads (no off-roading or towing, etc.).

Aug 09, 2023

The contact owns a 2016 Toyota Tundra. The contact stated while doing a routine check that it was discovered that the power steering assembly was leaking. The vehicle was diagnosed by an independent mechanic, and he stated that the power steering assembly needed to be replaced. The vehicle was not repaired. The dealer and the manufacturer were contacted, and they stated that the VIN was not included in NHTSA Campaign Number: 21E103000(Steering). The failure mileage was 53,437.

Aug 11, 2022

TL* THE CONTACT OWNS A 2016 TOYOTA TUNDRA. THE CONTACT STATED THAT THE RACK AND PINION FAILED WHILE THE VEHICLE WAS IN REVERSE. THE CONTACT STATED THAT THERE WAS FLUID FROM THE RACK AND PINION UNDERNEATH THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE RACK AND PINION SEAL FAILED. THE VEHICLE WAS TAKEN TO A SECOND INDEPENDENT MECHANIC AND THE FAILURE WAS CONFIRMED. PITTS TOYOTA (210 N. JEFFERSON ST, DUBLIN, GA 31021, (478)272-3244, WAS INFORMED OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 35,000.

Apr 30, 2020

FUEL/PROPULSION SYSTEM

4 complaints

Gas tank no longer fills completely in a single squeeze. Each squeeze of the pump only fills up maybe a .25 gallon at a squeeze if I am lucky, but typically less. This results in a complete fill up taking close to a half hour. There are numerous posts on forums such as https://www.tundras.com/threads/gas-filling-problem.38449/, https://www.tundras.com/threads/gas-tank-roll-over-valve-stuck-causes-hard-fuelling-anyone-else.42535/, and many others regarding this issue, with no response from dealers other than sorry. This sounds like a pure manufacturing issue if so many people have issues with their tanks, in a similar fashion.

Jun 26, 2023

Fuel gauge provides false inaccurate reading, resulting in stranded situation when fuel runs out. Toyota is aware is issue and has only issued a TSB for limited years when the problem is more wide spread. My daughter has been stranded several times.

Feb 27, 2023

My truck is shutting off while driving,can be very dangerous.

Jul 24, 2021

I PURCHASED TOYOTA TUNDRA ON 6 NOV 2015. SINCE OWNING THE VEHICLE I HAVE BEEN GETTING 460 MILES TO A FULL TANK OF GAS (38 GALLON TANK). THOSE NUMBERS EQUATE TO 12MPG IN FUEL ECONOMY ESTIMATES. I PICKED THE VEHICLE UP ON 6 NOV2015. THE TRUCK HAD A FULL TANK OF GAS. THE FUEL EFFICIENCY READ 570 MILE FOR A FULL TANK OF GAS. ON 13 NOV I DROVE THE VEHICLE TO FLORIDA. EVERY TIME I FILED UP THE TRUCK WITH FUEL THE FUEL EFFICIENCY READING STARTED TO DECLINE. ON THE FIRST THREE FULL TANK OF GAS, THE READING WAS 540 AND 520 MILES FOR A FULL TANK OF GAS ON 15 NOVEMBER. I TOOK THE VEHICLE TO THE DEALERSHIP ON OR ABOUT 17 NOV. THE SERVICE DEPARTMENT PLUGGED THE VEHICLE UP TO A COMPUTER. THE COMPUTER SENT OUT A REPORT THAT SHOWED THAT THE VEHICLE WAS GETTING 18 MPG. THE SERVICE PERSONNEL TOLD ME THAT I WOULD BE DOING WELL IF I GOT 14MPG. BASED ON THEIR COMMENTS I WAS NOT TO EXPECT ANYTHING OVER 15MPG OVER THE HIGHWAY. ON 25 NOV, I DROVE THE VEHICLE TO FLORIDA. I DECIDED TO MANUALLY TRACK THE MILEAGE IN REGARD TO A FULL TANK OF GAS WITH THE USE OF THE TRIP COUNTER. I TOOK PICTURES OF THE VEHICLE ONLY REGISTERING 12MPG ON A FULL TANK OF GAS. ON A FULL 38 GALLON TANK, I WAS ONLY ABLE TO DRIVE 460 MILES PER TANK. THAT EQUATE TO 12MPG. THE DRIVING CONDITION WAS 74-78 DEGREES; DRIVING ON I95; THERE WAS ONLY THREE PASSENGERS IN THE VEHICLE. I USED 89 OCTANE GRADED GAS.

Dec 07, 2015

UNKNOWN OR OTHER,SERVICE BRAKES

4 complaints

INTEGRATED TRAILER BRAKE CONTROLLER INTERMITENT FAILURE. TRAILER BRAKES WORK FOR A FEW BRAKING CYCLES THEN FAIL COMPLETELY WITH AN ERROR MESSAGE ON THE TRUCK OF "TRAILER WIRING TYPE, OR CONNECTION FAULT". TURNING THE VEHICLE OFF AND ON RESETS THE CONTROLLER AND "FIXES" THE PROBLEM UNTIL ANOTHER FEW BRAKING CYCLES, THEN REPEATS.

Jul 09, 2019

HAVE HAD BRAKING ISSUES WITH INTEGRATED BRAKE CONTROLLER, NO MATTER WHAT POWER LEVEL I USE THERE SEEMS TO BE VERY LITTLE IF NO EFFECT ON THE TRAILER BRAKING. I CAN SWITCH THE INTEGRATED BRAKE CONTROLLER TO ELECTRIC OVER HYDRAULIC AND THEY APPLY THE BRAKES AND THEY GRAB IMMEDIATELY, IT SEEMS THAT THE INTEGRATED BRAKE CONTROLLER IN ELECTRIC BRAKE MODE DOES NOT PRODUCE ENOUGH ELECTRICAL POWER TO ACTIVATE THE TRAILER BRAKES.

May 12, 2017

CPSC:I PURCHASED A 2016 TOYOTA TUNDRA PICKUP TRUCK. THE TRUCK COMES WITH AN INTEGRATED BRAKE CONTROLLER FOR TOWING TRAILERS, BOATS, ETC. THE IBC HAS TWO MODES OF BRAKING, FOR TRAILERS WITH ELECTRIC BRAKES OR FOR TRAILERS WITH HYDRAULIC BRAKES. *BF THE CONSUMER STATED THE AUTOMATIC BRAKING DID NOT WORK FOR THE ELECTRICS BRAKES MODE. UPDATED 04/21/2017 *JS

Apr 17, 2017

INTEGRATED BRAKE CONTROLLER DOES NOT OPERATE TRAILER BRAKES, AT ANY TIME. MOVING OR STANDING STILL.

Apr 05, 2017

AIR BAGS

3 complaints

TL* THE CONTACT OWNS A 2016 TOYOTA TUNDRA. WHILE DRIVING APPROXIMATELY 62 MPH, BOTH THE DRIVER AND PASSENGER SIDE CURTAIN AIR BAGS ERRONEOUSLY DEPLOYED WITHOUT WARNING OR IMPACT. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO SHELOR TOYOTA (2260 ROANOKE ST, CHRISTIANSBURG, VA), BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 30,000.

Mar 30, 2018

THE TUNDRA WITH A FRONT BENCH SEAT HAS NO AIR BAG FOR THE CENTER PASSENGER.

Sep 02, 2016

TOYOTA TUNDRA WITH FRONT BENCH SEAT HAVE NO AIR BAG FOR CENTER PASSENGER.

Apr 10, 2016

ELECTRICAL SYSTEM,SERVICE BRAKES

3 complaints

I PURCHASED A NEW TRAILER TO PICK UP MY NEW TRACTOR. I TESTED THE TRAILER BRAKES KNOWING I WAS PULLING A LARGE LOAD AND DIDN'T WANT AN ACCIDENT. THE BRAKES APPEARED TO APPLY BUT DUE TO IT NOT BEING LOADED WHEN TESTING I HAD IT SET TO 5(OUT OF 10). WHILE PULLING IT BACK HOME ON THE INTERSTATE TOWING MY TRACTOR BEHIND ME THERE WAS TRAFFIC STOPPING AHEAD. I ALWAYS DRIVE IN THE RIGHT LANE TO NOT SLOW OTHERS...THANK GOD I DID. I HAD TO DRIVE OFF THE ROAD ONTO THE SHOULDER TO MISS HITTING OR DRIVING OVER CARS AHEAD OF ME! THE BRAKES TURNED UP TO 10 DID NOTHING TO EVEN SLOW ME DOWN. I WAS TOWING 4 TONS AND 3 TONS FOR THE TRUCK TOTALING 7 TONS, SOMEONE WOULD'VE BEEN KILLED! TOYOTA NEEDS TO FIX THESE TRAILER BRAKES! I CAN'T TOW MY TRACTOR ANYWHERE FOR WORK DUE TO THE BRAKES BEING UNSAFE!

Jan 11, 2018

Crash: 1

TL* THE CONTACT OWNS A 2016 TOYOTA TUNDRA. WHILE TOWING A TRAILER, THE BRAKE PEDAL WAS DEPRESSED; HOWEVER, THE TRAILER BRAKE LIGHTS FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE INTEGRATED BRAKE CONTROLLER FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 500. THE VIN WAS NOT AVAILABLE.

Sep 21, 2016

THE INTEGRATED BRAKE CONTROLLER IS NOT WORK WHEN APPLYING THE BRAKES IN ELECTRIC BRAKE MODE. TOOK MY TUNDRA OUT FOR A TEST DRIVE WITH MY 24' 3200 LB TRAVEL TRAILER. I SET THE GAIN TO 10 AND HIT THE MANUAL SLIDE AND THE TRAILER TIRES LOCKED UP. STEPPED ON THE BRAKES AND COULDN'T FEEL ANY BRAKES BEING APPLIED TO THE TRAILER. I WOULD HAVE EXPECTED THE TRAILER TIRES TO LOCKUP WHEN I HIT THE BRAKES WITH A GAIN OF 10. THIS COULD MAKE A VERY DANGEROUS SITUATION.

Jun 07, 2016

SUSPENSION

2 complaints

What component or system failed or malfunctioned, and is it available for inspection upon request? Answer - Front and rear wheel bearings. How was your safety or the safety of others put at risk? Answer - wheels could have locked up while driving. Has the problem been reproduced or confirmed by a dealer or independent service center? Answer - Yes. Milton Martin Toyota in Oakwood, GA has confirmed that 3 wheel bearings are bad and need to be replaced. 1x front left wheel bearing replaced on 12/06/21 and both rear wheel bearings are being replaced on 12/14/21. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Answer - Yes, if a dealership qualifies as the manufacturer. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Answer - Yes, noise from the wheels while driving. No warning lamps or messages. I noticed the "roaring" noise around 11/12/2021.

Dec 14, 2021

TL* THE CONTACT OWNS A 2016 TOYOTA TUNDRA. WHILE DRIVING VARIOUS SPEEDS, THE BALL JOINT FAILED AND DAMAGED THE VEHICLE. THE VEHICLE WAS TOWED TO DEALER FOR DIAGNOSTIC TESTING, BUT THE RESULTS WERE NOT PROVIDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 14,000.

Jul 01, 2016

WHEELS

2 complaints

WHILE CHECKING AIR PRESSURE IN TIRES AND TPMS SENSOR SNAPPED OFF

Jan 30, 2020

AT ONLY 77,000 MILES THE AXLE BEARINGS HAVE FAILED. THIS IS UNBELIEVABLE SINCE SEALED BEARINGS ARE SUPPOSED TO LAST THE LIFETIME OF THE VEHICLE. THE TOYOTA DEALERSHIP PARTS MANAGER SAYS THESE BEARINGS FAIL FREQUENTLY ON THE TUNDRAS.

Apr 20, 2019

TIRES

2 complaints

TL* THE CONTACT OWNS A 2016 TOYOTA TUNDRA EQUIPPED WITH KUMHO ROAD VENTURES TIRES, SIZE: 275/65R/20 (NA). THE CONTACT STATED THAT THE VEHICLE EXPERIENCED SEVERE SHAKING DUE TO THE STEERING COLUMN WHILE TRAVELING APPROXIMATELY 65 MPH. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TIRE TREAD SHIFTED ON THE PASSENGER SIDE TIRE. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE DOT NUMBER AND TIRE AND VEHICLE FAILURE MILEAGE WERE NOT PROVIDED.

Nov 27, 2017

ON OUR 2016 TOYOTA TUNDRA 4X4 CREW CAB TRUCK MY TIRES ARE ALREADY WORN OUT. THEY ONLY HAVE 17000 MILES ON THEM. THE TREAD ON THE TIRES ARE 5/30 2ND. WE ROTATE EVERY 3000 TO 5000 MILES. WE PURCHASED THIS TRUCK FOR TOWING OUR 20 FT TRAILER AND HAVE TAKEN 3 SHORT VACATIONS (ABOUT 1 WEEK EACH) AND THERE IS HARDLY ANY TREAD LEFT ON THEM. WE ARE SENIOR CITIZENS AND DO NOT DRIVE RECKLESSLY. PLEASE ADVISE ON WHAT TO DO WITH TAKING THESE ON MORE TRIPS. I DO HAVE PICTURES OF MY TIRES IF NEEDED.

Jun 12, 2017

UNKNOWN OR OTHER,STRUCTURE

1 complaint

I have had multiple incidents where the front hood bulge has blown off going down the interstate and nearly hit other cars. It’s not been worth buying a new one with the risk of them flying off. It’s definitely a saftey concern and a hazard.

Mar 20, 2025

STRUCTURE,UNKNOWN OR OTHER

1 complaint

The frame of the truck is extremely rusted. I am unsure if it can be fixed. It is available for inspection. This 2016 Tundra has 71,000 miles and is used as a third car. It has been serviced at the same dealership (Northshore Toyota, Covington, LA) and we were never informed of the damage by the dealership. My safety is at risk because the extensive rust could cause the frame to fail. Previous Tundra models have been recalled because of the same issues. No warnings were issued even after the dealership serviced the truck on a lift numerous times (approximately 9 years). The only previous warning by the dealership was on 1/29/2025 when the dealership informed us of a rusty trailer hitch. The truck was brought to 4 body shops in the local area after the owner went to work on the trailer hitch and saw the damage. All 4 shops confirmed that the rust was extensive. 3 shops would not fix the damage because it would be an expensive/extensive fix. We are waiting on what shop #4 says.

Feb 17, 2025

ENGINE

1 complaint

Problem Parts?? At around 70,000 miles I was told that there was an engine oil leak ... camshaft area... and the engine needs to pulled out with a repair cost of about $5,000 dollars. (Reseal both cam towers, replace gaskets, etc.) A bit ridiculous. Is there now a possible engine fire risk? At 70,000 miles there was obviously a manufacturing mistake or a defective part used during assembly.

Nov 14, 2024

STEERING,ELECTRICAL SYSTEM,SERVICE BRAKES

1 complaint

1)Over 60 MPH with new tires the vehicle pulses & shakes on front end, checked alignment everything OK per Mechanic. Just started to occur 2)Bluetooth when on iPhone will at any time cut out guaranteed to occur when using at any time been occurring for 2 + years. 3)Trailer brake warning light (Idiot light) comes on dashboard does not recommend trailering due to electrical issue. occurring for 2+ years Bought vehicle used in 2017 with 13k on Truck now 2024 has 91K on truck love the truck but zero recalls for any of the above?

Jun 05, 2024

POWER TRAIN

1 complaint

The contact owns a 2016 Toyota Tundra. The contact stated that the oil change warning light was illuminated. The contact changed the oil however, after changing the oil, the vehicle would not shift into the intended gear. The vehicle was taken to the dealer and the contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 73,400.

Feb 16, 2023

POWER TRAIN,ENGINE

1 complaint

Under acceleration the truck hesitates during shifting. Took to dealership and they can’t find anything however it continues intermittently. During speeds on highway it does the same. No codes so the dealership said it would just have to continue until something triggered or became more frequent. To date this continues. Started seeing the random issue around Feb 2021

May 30, 2021

POWER TRAIN,WHEELS

1 complaint

REAR WHEEL BEARINGS FAILED (BUT STILL FUNCTIONAL) AT 17000 MILES. WHEELS STILL ROTATE BUT THERE IS A VERY LOUD DRONING NOISE AT HIGHWAY SPEEDS WITH A SLIGHT SQUEAL AT LOWER SPEEDS. NON-TOYOTA MECHANICS HAVE EXPRESSED CONCERNS ABOUT DRIVING THE VEHICLE AS BEARINGS CAN FAIL ALTOGETHER AND SEIZE THE WHEELS.

Jul 09, 2020

ELECTRICAL SYSTEM,UNKNOWN OR OTHER

1 complaint

THE POWER LOCKS FOR THE FRONT DRIVER SIDE AND PASSENGER SIDE FAIL TO WORK AS EXPECTED. IT IS NOT CONSISTENT. WHEN DRIVING, IT IS SUPPOSED TO LOCK AUTOMATICALLY FOR SAFETY BUT DOES NOT ALWAYS LOCK (OR UNLOCK WITH THE KEY FOB WHEN NEEDING TO GET INTO THE VEHICLE. PROBLEM OCCURS WHEN VEHICLE IS STATIONARY OR MOVING.

Mar 05, 2020

AIR BAGS,SEAT BELTS

1 complaint

2016 TOYOTA TUNDRA. CONSUMER STATES THAT AIR BAGS DID NOT DEPLOY AND SEAT BELTS DID NOT LOCK DURING COLLISION. *LD *JS

Dec 30, 2019

Crash: 1

WHEELS,UNKNOWN OR OTHER

1 complaint

REAR WHEEL OR AXLE BEARINGS MAKE A NOTICEABLE LOUD HUMMING SOUND WHEN DRIVING AT ROAD SPEED LIMIT, ESPECIALLY WHEN MOVING SLIGHTLY LEFT INTO A CURVE OR RIGHT INTO A CURVE.

Aug 09, 2019

STRUCTURE,SEATS

1 complaint

TL* THE CONTACT OWNS A 2016 TOYOTA TUNDRA. UPON INSPECTING THE VEHICLE, THE CONTACT NOTICED RUST ON THE FRAME OF THE REAR SEAT. THE VEHICLE WAS TAKEN TO HERTRICH TOYOTA OF MILFORD (1367 BAY RD, MILFORD, DE 19963, (877) 458-0609) WHERE THE CONTACT WAS INFORMED THAT THE CAUSE OF THE FAILURE WAS DUE TO MOISTURE ENTERING THE VEHICLE. THE CONTACT CLEANED THE RUST, BUT THE FAILURE RECURRED WITH EVEN MORE RUST. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 31,000.

Apr 23, 2019

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,ENGINE

1 complaint

THE VEHICLE WAS STRUCK BY LIGHTNING ON 8/13/17. THE DEALERSHIP WHERE WE BOUGHT THIS VEHICLE NEW AGREED TO FIX IT THROUGH OUR INSURANCE CLAIM AND PROVIDES A LIFETIME WARRANTY ON THE REPAIRS. THE VEHICLE CONTINUES TO HAVE PROBLEMS. SEE THE ATTACHED LIST OF DAMAGES, WHICH WERE PROVIDED TO THE DEALERSHIP ON 1/15/18. WHEN I DROPPED IT OFF I INDICATED THE VEHICLE WAS MALFUNCTIONING AGAIN WITHOUT THE CRUISE CONTROL ENGAGED. THE DEALERSHIP CALLED TODAY AND VERY RUDELY STATED THEY COULD NOT RECREATE THE PROBLEM AND WILL NOT FIX THE VEHICLE. THE VEHICLE IS UNSAFE TO DRIVE BECAUSE OF SOME OF THE ISSUES. WHEN I ASKED TO SPEAK TO THE CUSTOMER SERVICE MANAGER, THE RECEPTIONIST REFUSED AND SAID THEY WILL NOT FIX MY VEHICLE.

Jan 17, 2018

SUSPENSION,STRUCTURE

1 complaint

2016 TOYOTA TUNDRA , PURCHASED BRAND NEW , AFTER 3000 MILES TRUCK START LEANING TOWARDS THE PASSENGER SIDE. I EXPRESSED ISSUE TO THE DEALER, TECHNICIAN TOOK FOR A DRIVE TEST AND NOTICED THE SAME ISSUE , I DROPPED MY VEHICLE WITH DEALER FOR A COUPLE OF DAYS AND NOTHING WAS DONE TO IT DUE TO THERE IS NO RECALLS TO IT, BUT I PERSONALLY BELIEVE THIS IS A SAFETY CONCERN AND SHOULD BE PREVENTED .

Dec 21, 2016

ELECTRICAL SYSTEM,EXTERIOR LIGHTING,VEHICLE SPEED CONTROL

1 complaint

I HAVE A SERIOUS SAFETY CONCERN REGARDING THE LACK OF DAYTIME VEHICLE INSTRUMENT ILLUMINATION ON MY NEW 2016 TOYOTA TUNDRA (WHILE DRIVING, STATIONARY AND ON ALL ROADS) DURING THE DAY. AS AN ELDER ADULT WHO WEARS SUNGLASSES TO PROTECT THEIR EYES (ON THE RECOMMENDATION OF THE MEDICAL PROFESSION) THE DASH BOARD (SPECIFICALLY THE SPEEDOMETER INDICATOR) IS BARELY DISCERNIBLE. EVEN WITHOUT SUNGLASSES THE INSTRUMENT PANEL IS VERY DARK. I AM SURE THERE ARE THOUSANDS OF OTHERS WHO WOULD LIKE TO SEE THE INSTRUMENTS AND OPERATE THEIR VEHICLES IN A SAFE AND LAWFUL MANNER DURING THE DAYTIME OR WITH SUNGLASSES ON. I AM SURE THE DECISION, BY TOYOTA, TO NOT ILLUMINATE THE DASH IN THE DAYTIME SAVES A FEW PENNIES AND ADDS UP FOR THE MANUFACTURER WHEN YOU SELL THOUSANDS OF VEHICLES? BUT. . . NOT BEING ABLE TO SEE A DARK INSTRUMENT PANEL IS BOUND TO CAUSE MORE THAN A FEW ACCIDENTS.

Nov 15, 2016

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,SERVICE BRAKES

1 complaint

THE INTEGRATED ELECRIC BRAKE CONTROLLER INCLUDED IN MY PLATINUM EDITION OPTIONS FOR TOWING A TRAILER DOES NOT WORK. ACCORDING TO DEALER, THERE IS NO FIX FROM TOYOTA ALTHOUGH THEY ARE AWARE OF THE ISSUE.

Oct 17, 2016

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,UNKNOWN OR OTHER

1 complaint

RE: INTEGRATED BREAK CONTROLLER I WANTED TO EXPRESS A SERIOUS SAFETY CONCERN I HAVE WITH AN ITEM THAT NOW SHIPS WITH THE 2016 TOYOTA 5.7L TUNDRA'S - THE BUILT IN / INTEGRATED BREAK CONTROLLER FOR USE WHEN PULLING TRAILERS/CAMPERS/ETC. IT SEEMS THAT REGARDLESS OF THE POWER SETTING, NO NOTICEABLE POWER IS SUPPLIED TO THE TRAILER BRAKES, EVEN AT IT'S HIGHEST SETTING. IT FEELS LIKE THE TRAILER/CAMPER IS PUSHING THE TRUCK, WHICH CAN BE A SERIOUS ISSUE WHEN STOPPING. THIS WOULD HAPPEN EVERY TIME I WOULD TOW AND I WAS ALWAYS VERY WORRIED ABOUT CAUSING AN ACCIDENT IF I NEEDED TO STOP QUICKLY OR IF THE ROAD CONDITIONS WERE NOT IDEA. I'VE NEVER FELT THIS WITH OTHER BREAK CONTROLLERS. IT'S MY UNDERSTANDING TOYOTA HAS NOT ACKNOWLEDGED THIS AS BEING AN ISSUE YET. AFTER TALKING TO MANY OTHER TUNDRA OWNERS EVERYONE HAS THE SAME ISSUE, I'VE NOT TALKED TO ANYONE THAT HAS A WORKING INTEGRATED BREAK CONTROLLER IN THEIR 2016. I'VE TAKEN OUT MY INTEGRATED BREAK CONTROLLER THAT CAME IN MY 2016 TOYOTA TUNDRA AND REPLACED IT WITH AN AFTER MARKET BRAKE CONTROLLER OUT SO I CAN PROPERTY BRAKE WITH MY CAMPER ATTACHED. FOR NOW MY ISSUE IS RESOLVED, HOWEVER, I AM HOWEVER VERY WORRIED ABOUT OTHERS THAT MIGHT BE USING THE INTEGRATED BREAK CONTROLLER AND THE HUGE POTENTIAL FOR A SERIOUS ACCIDENT BECAUSE THEIR TRAILER OR CAMPER BRAKES ARE NOT WORKING. PLEASE LOOK INTO THIS BEFORE ANY SERIOUS ACCIDENTS HAPPEN. THANKS!

Jun 13, 2016

STEERING,UNKNOWN OR OTHER

1 complaint

2016 TUNDRA CREW MAX XPSX PACKAGE, 4X4. VIBRATION IN STEERING WHEEL AT ALL SPEEDS. SOUTHEAST TOYOTA STATES THAT THE PROBLEM IS JUST A OPERATIONAL CHARACTERISTIC OF THE TRUCK.

Jan 18, 2016

VISIBILITY/WIPER

1 complaint

THE WIPER SPEED, WHILE ON HIGH IS NOT FAST ENOUGH FOR A MODERATE RAINFALL. I WAS CAUGHT IN A SLIGHTLY ABOVE AVERAGE DOWNPOUR ON THE HIGHWAY AND I HAD TO REDUCE MY SPEED BY ALMOST 40MPH TO GET A LITTLE VISIBILITY BACK. ALL OTHER VEHICLES NEAR ME FLEW RIGHT PAST WITH THEIR WIPERS ON HIGH WITHOUT ANY ISSUE. THEY NEED TO SPEED UP THE WIPER MOTOR.

Jan 12, 2016

POWER TRAIN,ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES

1 complaint

THE DRIVETRAIN ON MY 2016 TOYOTA TUNDRA ARE NOT ALLOWING THE WHEELS TO ROTATE FREELY. ADDITIONALLY, THE WHEELS ARE LOCKING UP ON THE TRUCK. ON 6 DEC, I PICKED UP MY TUNDRA FROM THE DEALERSHIP'S SERVICE DEPART AFTER HAVING THE REAR DIFFERENTIAL REPAIRED. THE VEHICLE STARTED TO DRIVE SLUGGISH. AS I NEARED MY HOME, I TRIED TO TEST THE 2WD AND 4WD FUNCTIONS OF THE VEHICLE. I ATTEMPTED TO TEST THE REPAIR THAT WAS DONE. THE WHEELS ON THE VEHICLE STARTED TO HAVE PROBLEMS ROTATING FREELY AND LOCKING UP. WHILE IN 4WD THE VEHICLE WOULD NOT MOVE. IT APPEARED AS IF THE BREAKS WERE LOCKED ON THE VEHICLE. FOUR DAYS LATER, THE VEHICLE STILL DRIVES SLUGGISH. WHILE DRIVING AT SPEEDS OF 45MPH, I WOULD TAKE MY FOOT OFF THE ACCELERATOR AND THE VEHICLE WOULD ALMOST COME TO A COMPLETE STOP ON ITS OWN. CURRENTLY THE VEHICLE ACTS LIKE IT WANTS TO DRIVE IN 4WD LOW AND HIGH MODE. ADDITIONALLY, THE WHEELS ARE ACTING LIKE THEY DO NOT WANT TO ROTATE FREELY. AS OF 6AM ON 8 DEC, I CANNOT DRIVE THE VEHICLE OVER 25 MPH. THE VEHICLE IS IDLING OVER 4000 RPM AND NOT CHANGING GEARS. THE VEHICLE IS REGISTERING BEING IN 4WD LOW BUT THE SELECTOR SWITCH IS ON 2WD MODE.

Dec 08, 2015

POWER TRAIN,SERVICE BRAKES

1 complaint

WHILE DRIVING BACK FROM FLORIDA ON 30 NOV, I HEARD A HUMMING NOISE COMING FROM THE REAR OF MY TOYOTA TUNDRA. ON 2 DEC 2015, THE DEALERSHIP DID SERVICE ON THE TRUCK TO ADDRESS THE NOISE. THE DEALERSHIP REPLACED THE REAR DIFFERENTIAL ASSEMBLY AND DID SOMETHING TO THE LSD. I PICKED THE VEHICLE UP ON 6 DECEMBER 2015, THE REAR WHEELS STARTED LOCKING UP AND MADE IT DIFFICULT TO DRIVE THE VEHICLE. I LET THE VEHICLE SET OVER THE WEEKEND. ON 7 DEC 2015, I ATTEMPTED TO DRIVE THE VEHICLE AGAIN, THE WHEELS WERE STILL LOCKING UP AND THE VEHICLE HAD A BURNING SMELL. I HAVE AN APPOINT TO RETURN THE VEHICLE ON 9 DEC 2015.

Dec 07, 2015

4.9/5.0

44 reviews

Where to Find VIN for Problems Check

To check for problems and complaints on your 2016 TOYOTA Tundra, you'll need the VIN number. Find your VIN in one of these 4 common locations.

Where to Find VIN Number on 2016 TOYOTA Tundra for Problems Lookup - Dashboard, Door Jamb, Engine Bay, Documents

Understanding VIN Structure for Problem Reports

Each character in your 2016 TOYOTA Tundra 17-digit VIN helps identify specific complaints and problems affecting your vehicle model.

2016 TOYOTA Tundra VIN Structure for Complaint Verification - WMI, VDS, Check Digit, Model Year, Plant Code

How to Check 2016 TOYOTA Tundra Problems in 3 Steps

Locate Your VIN

Find the 17-character VIN on your 2016 TOYOTA Tundra dashboard (visible through windshield), door jamb, engine bay, or vehicle documents.

Review by Component

Browse owner-reported complaints organized by vehicle component (engine, transmission, brakes, electrical) to identify common issues and problem patterns for this model year.

Check Safety Issues

Review crash and fire incidents for each component to assess safety concerns. Contact your TOYOTA dealer or report problems to NHTSA at SaferCar.gov.

Frequently Asked Questions

How many problems does the 2016 TOYOTA Tundra have?

The 2016 TOYOTA Tundra currently has 114 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2016 TOYOTA Tundra?

The most common problems reported for the 2016 TOYOTA Tundra are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2016 TOYOTA Tundra problem data come from?

All problem and complaint data for the 2016 TOYOTA Tundra comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.

How do I report problems with my 2016 TOYOTA Tundra?

You can report safety problems with your 2016 TOYOTA Tundra directly to NHTSA at SaferCar.gov or call 1-888-327-4236. Your complaint helps identify patterns and may lead to recalls or investigations.

Where can I find my VIN to check problems?

Your 2016 TOYOTA Tundra VIN is located in 4 places: (1) Dashboard near windshield on driver's side, (2) Driver's door jamb sticker, (3) Engine bay, (4) Vehicle registration and insurance documents.

Is the 2016 TOYOTA Tundra reliable?

Reliability can be assessed by reviewing the number and severity of owner complaints for the 2016 TOYOTA Tundra. Check complaints by component, crash reports, and fire incidents above to evaluate potential issues and problem patterns.