2019 AUTOCAR Xpeditor Recalls & Safety Issues
Official recalls, technical service bulletins (TSBs), and safety issues from the National Highway Traffic Safety Administration (NHTSA).
VIN Decoder
24
Recalls Found
As an Amazon Associate, ForCar.org earns from qualifying purchases.
All Recalls
Autocar, LLC (Autocar) is recalling certain 2019-2020 Xpeditor vehicles. The rear axle brake may have a delayed release. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems."
NHTSA 19V354000
Consequence: A delayed brake release may increase the risk of crash.
Remedy / Corrective Action
Autocar will notify owners, and dealers will re-work the air brake systems, free of charge. The recall began July 8, 2091. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-1905.
Autocar, LLC (Autocar) is recalling certain 2019 Autocar Xpeditor vehicles. The universal joint strap bolts at the transmission output yoke may not be have been properly tightened.
NHTSA 18V889000
Consequence: If the universal joint strap bolts are loose, the strap may disconnect from the vehicle and the drive shaft could detach, increasing the risk of of a crash.
Remedy / Corrective Action
Autocar has notified owners, and dealers will properly tighten the universal joint strap bolts, free of charge. The recall began January 29, 2019. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-1901.
Autocar, LLC. (Autocar) is recalling certain 2020 Xpeditor vehicles up-fitted with an aftermarket power take off (PTO). The engine may stall or hesitate when operated from the right-side stand-up position with the PTO system engaged.
NHTSA 21V930000
Consequence: A stall or hesitation can cause the vehicle to roll backwards, increasing the risk of a crash or personal injury.
Remedy / Corrective Action
Autocar will install a hill start aide system, free of charge. Owner notification letters were mailed January 24, 2022. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-2107. Note: This recall is an expansion of recall 20V-496.
Autocar, LLC (Autocar) is recalling certain 2019-2022 Xpeditor and 2020-2022 Legend vehicles. The fuel tubes between the fuel rail and the injectors for cylinders four, five, and six may fatigue and crack, which can result in a high pressure fuel leak.
NHTSA 21V956000
Consequence: A high pressure fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy / Corrective Action
Cummins will replace the fuel tubes, and install vibration isolators, free of charge. Interim owner notification letters explaining the safety risk were mailed January 28, 2022. Owner notification letters were mailed on March 11, 2022. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-976-3486. Autocar's number for this recall is ACX-2108 DC-2105.
Autocar, LLC (Autocar) is recalling certain 2016-2020 Autocar Xpeditor vehicles equipped with Wabco Automatic Traction Control (ATC) electronic control units (ECU). The ATC ECUs may not be programmed correctly and may malfunction without warning.
NHTSA 20V257000
Consequence: An ATC ECU malfunction may increase the risk of a crash.
Remedy / Corrective Action
Autocar will notify owners, and dealers will reprogram the ATC ECU, free of charge. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. The recall began July 6, 2020. Autocar's number for this recall is ACX-2002.
Autocar, LLC (Autocar) is recalling certain 2019-2021 Xpeditor and 2021-2022 Legend vehicles equipped with a MRS 7" display. The display may restart during operation, resulting in the warning lights not being visible until the restart is completed. The display may restart during operation and the warning icons for the Seat Belt, Low Air, Check Engine, ABS, Park Brake Applied, Turn Signal Indicator, Fuel Level, Electrical Charge, Coolant Temperature and Oil Pressure will not be visible until restart has completed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Control and Displays."
NHTSA 21V093000
Consequence: During a display restart, warning lights such as the seat belt, check engine, fuel level, and other important warnings may not display, increasing the risk of a crash or injury.
Remedy / Corrective Action
Autocar will notify owners, and dealers will replace the display, free of charge. Interim notices informing owners of the safety risk were mailed April 19, 2021. A second notice will be sent when the remedy becomes available in February 2022. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-2102- DC-2101.
Autocar, LLC (Autocar) is recalling certain 2019 Xpeditor vehicles equipped with factory installed methane detection systems. The circuit protection of the detection system may be inadequate, and its wiring harness may overheat.
NHTSA 20V545000
Consequence: An overheated wiring harness increases the risk of a fire.
Remedy / Corrective Action
Autocar will notify owners, and dealers will replace the ten amp fuse for the methane detector with a three amp fuse, free of charge. The recall began November 6, 2020. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-2006.
Autocar, LLC (Autocar) is recalling certain 2018-2021 Xpeditor vehicles. The turbocharger heat shield may fail and detach from the vehicle.
NHTSA 21V095000
Consequence: A detached heat shield can become a road hazard, increasing the risk of a crash or injury.
Remedy / Corrective Action
Autocar will notify owners, and dealers will replace the turbocharger heat shield, free of charge. Owner notification letters were mailed on June 24, 2021. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-2103.
Autocar, LLC (Autocar) is recalling certain 2019-2022 Xpeditor vehicles. The hazard lights will not function with the ignition turned off. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
NHTSA 21V867000
Consequence: Disabled hazard lighting can increase the risk of a crash or injury in a hazard situation.
Remedy / Corrective Action
Dealers will reprogram the hazard lighting software, free of charge. Interim owner notification letters informing owners of the safety risk were mailed January 07, 2022. Owner notification letters were mailed on March 17, 2022. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-2106.
Autocar, LLC (Autocar) is recalling certain 2008-2019 Xpeditor vehicles. The affected vehicles are equipped with undersized brake chambers, possibly allowing the truck to roll when parked. As a result, the vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air brake systems."
NHTSA 19V091000
Consequence: Unexpected movement when parked can increase the risk of crash.
Remedy / Corrective Action
Autocar will notify owners, and dealers will replace the parking brake chambers with ones of the proper size, free of charge. The recall began April 16, 2019. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-1903.
Autocar, LLC (Autocar) is recalling certain 2018-2021 Xpeditor vehicles. These vehicles may have a seat belt harness routing located too close to the seat mechanism. If the harness chafes and short circuits, the circuit protection fuse will open, and the engine will shut off and not restart.
NHTSA 21V030000
Consequence: The vehicle may stall and not restart, without warning, increasing the risk of a crash, personal injury or property damage.
Remedy / Corrective Action
Autocar will notify owners, and dealers will route and secure the seatbelt wiring clear of the seat mechanism, free of charge. The recall began on March 25, 2021. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-2101.
Autocar, LLC is recalling certain 2019 Xpeditor vehicles up-fitted with an aftermarket power take off (PTO). These vehicles may stall or hesitate when operated from the right side stand up position with the PTO system engaged.
NHTSA 20V496000
Consequence: A stall or hesitation can cause the vehicle to drift backwards, increasing the risk of a crash, personal injury ,or property damage.
Remedy / Corrective Action
Autocar will notify owners of the recall on October 19, 2020. Dealers will install a hill start aid system, free of charge. Autocar issued owners an interim notification on October 20, 2020. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3488. Autocar's number for this recall is ACX-2005.
Autocar, LLC (Autocar) is recalling certain 2019 Autocar Xpeditor vehicles. The power steering assist cylinder bracket may not be properly secured to the frame rail, possibly causing an increase in steering effort or a loss of steering ability.
NHTSA 18V815000
Consequence: A reduction of power steering assist or a loss of steering control can increase the risk of a crash.
Remedy / Corrective Action
Autocar will notify owners, and dealers will properly secure the power assist steering bracket to the frame, free of charge. The recall began December 18, 2018. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-1803.
Autocar, LLC (Autocar) is recalling certain 2018-2021 Xpeditor trucks with a right-hand drive cab configuration equipped with a park brake valve (button) located to the right of the steering wheel. The parking brake synchronization valve plumbing may be improperly assembled, causing the parking brake to apply unexpectedly without warning.
NHTSA 20V450000
Consequence: Unexpected parking brake application can increase the risk of a crash.
Remedy / Corrective Action
Autocar will notify owners, and dealers will correct the plumbing to allow the system to operate as designed. The recall began September 28, 2020. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3488. Autocar's number for this recall is ACX-2004.
Autocar, LLC (Autocar) is recalling certain 2019-2020 Xpeditor vehicles. The power steering mounting bolts may loosen, possibly causing the power steering pump to disconnect.
NHTSA 19V622000
Consequence: A disconnected power steering pump can cause a sudden increase of steering effort resulting in a loss of vehicle control, increasing the risk of a crash.
Remedy / Corrective Action
Autocar will notify owners, and dealers will properly secure the power steering mounting bolts, free of charge. The recall began October 17, 2019. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-1907.
Autocar, LLC (Autocar) is recalling certain 2013-2020 Xpeditor vehicles. The ignition relay may fail without warning, causing the vehicle to stall.
NHTSA 20V013000
Consequence: A vehicle stall can increase the risk of crash.
Remedy / Corrective Action
Autocar will notify owners, and dealers will replace the ignition relay, free of charge. Autocar issued owners an interim notification on March 12, 2020. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-2001.
Autocar, LLC (Autocar) is recalling certain 2019-2020 Xpeditor vehicles. The brake chamber clevis pin retainer may not have be been installed, possibly increasing the distance needed to stop the vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems."
NHTSA 19V227000
Consequence: Additional distance needed to stop the vehicle may increase the risk of crash.
Remedy / Corrective Action
Autocar will notify owners, and dealers will install any missing brake chamber clevis pin retainers, free of charge. The recall began May 20, 2019. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-1904.
Autocar, LLC (Autocar) is recalling certain 2018-2019 Autocar Xpeditor vehicles. The pinch bolt on the clamp for the adjustable length drag link may not have been properly tightened.
NHTSA 18V224000
Consequence: If the pinch bolt loosens, there may be a loss of steering control, increasing the risk of a crash.
Remedy / Corrective Action
Autocar will notify owners, and dealers will inspect the drag link pinch bolt, tightening it as necessary, free of charge. The recall began on May 25, 2018. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-1802.
Autocar, LLC (Autocar) is recalling certain 2019-2021 Xpeditor (ACX) vehicles. The hazard lights will not function when the ignition is off. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
NHTSA 22V262000
Consequence: Inoperable hazard lights increase the risk of a crash.
Remedy / Corrective Action
Dealers will repair or replace the wire harness, free of charge. Owner notification letters are expected to be mailed on June 13, 2022. Owners may contact Autocar's customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-2202.
Autocar, LLC (Autocar) is recalling certain 2019-2022 Xpeditor (ACX) trucks. The external fuse box may short circuit due to water intrusion.
NHTSA 22V437000
Consequence: A fuse box that short circuits can cause an unexpected vehicle stall, increasing the risk of a crash.
Remedy / Corrective Action
Dealers will mount the external fuse box vertically and install a shield, free of charge. Owner notification letters are expected to be mailed on August 15, 2022. Owners may contact Autocar's customer service at 1-888-218-3611. Autocar's number for this recall is ACX-2203.
Autocar, LLC (Autocar) is recalling certain 2012-2016 Xpert, 2010-2020 Xspotter, 2008-2020 Xpeditor, 2008-2010 WXLL and WX vehicles. A worn parking brake control valve can leak air into the vent line, creating excessive back pressure and causing the parking brake to release unexpectedly.
NHTSA 23V023000
Consequence: The unexpected release of the parking brake may allow the vehicle to rollaway, increasing the risk of a crash.
Remedy / Corrective Action
Dealers will remove the vent line and fitting from the valve, free of charge. Owner notification letters were mailed March 23, 2023. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's number for this recall is ACX-2023 ACTT-2301.
Autocar, LLC (Autocar) is recalling certain 2016-2023 ACX (Xpeditor) and 2020-2023 DC (Legend) vehicles. The park brake warning light may incorrectly illuminate during an air loss event. As such, these trucks fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
NHTSA 23V400000
Consequence: A park brake warning light that illuminates incorrectly increases the risk of a crash.
Remedy / Corrective Action
Dealers will replace the pressure switch, free of charge. Owner notification letters were mailed July 31, 2023. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's numbers for this recall is ACX-2307 and DC-2303.
Autocar, LLC (Autocar) is recalling certain 2016-2023 ACX (Xpeditor) and 2021-2023 DC (Legend) vehicles. The park brake warning light may incorrectly illuminate during an air loss event. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
NHTSA 23V699000
Consequence: A park brake warning light that illuminates incorrectly increases the risk of a crash.
Remedy / Corrective Action
Dealers will replace the pressure switch, free of charge. Owner notification letters were mailed January 2, 2024. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's numbers for this recall are ACX-2311 and DC-2306. This recall is an expansion of recall number 23V-400.
Autocar, LLC (Autocar) is recalling certain 2015-2022 ACTT (Xspotter) and ACX (Xpeditor) vehicles. The air tanks have an insufficient volume of air for the brake system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 121, "Air Brake Systems."
NHTSA 25V449000
Consequence: Insufficient air volume can reduce brake function, extending the distance required to stop and increasing the risk of a crash.
Remedy / Corrective Action
Dealers will inspect and replace or add additional air tanks as necessary, free of charge. Interim owner notification letters explaining the safety risk were mailed August 29, 2025. Owners will receive a second notice once remedy parts become available, anticipated mid-January 2025. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's numbers for this recall are ACTT-2503 and ACX-2503.
Where to Find VIN for Recall Check
To check for recalls on your 2019 AUTOCAR Xpeditor, you'll need the VIN number. Find your VIN in one of these 4 common locations.
Understanding VIN Structure for Recall Verification
Each character in your 2019 AUTOCAR Xpeditor 17-digit VIN helps identify specific recalls affecting your vehicle. Learn how the VIN structure works for accurate recall lookup.
How to Check 2019 AUTOCAR Xpeditor Recalls in 3 Steps
1
Locate Your VIN
Find the 17-character VIN on your 2019 AUTOCAR Xpeditor dashboard (visible through windshield), door jamb, engine bay, or vehicle documents.
2
Enter VIN in Checker
Input your VIN into our free recall checker tool above to search NHTSA database for safety recalls, TSBs, and service campaigns specific to your vehicle.
3
Review & Schedule Repair
Check the recall details including affected components, consequences, and remedy. Contact your AUTOCAR dealer to schedule free recall repair appointment.
Frequently Asked Questions
How many recalls does the 2019 AUTOCAR Xpeditor have?
The 2019 AUTOCAR Xpeditor currently has 24 recalls according to NHTSA records. All recall information is sourced directly from the National Highway Traffic Safety Administration database.
Are 2019 AUTOCAR Xpeditor recalls free to fix?
Yes! All safety recalls for 2019 AUTOCAR Xpeditor vehicles must be repaired free of charge by authorized dealers, regardless of vehicle age or mileage. Contact your local AUTOCAR dealer to schedule a recall repair.
How do I check if my 2019 AUTOCAR Xpeditor has open recalls?
You can check for open recalls by entering your VIN (Vehicle Identification Number) in our VIN decoder tool. The 17-character VIN can be found on your vehicle registration, insurance card, or on the driver's side dashboard visible through the windshield.
Where can I find my 2019 AUTOCAR Xpeditor VIN number?
Your 2019 AUTOCAR Xpeditor VIN is located in 4 places: (1) Dashboard near windshield on driver's side, (2) Driver's door jamb sticker, (3) Engine bay, (4) Vehicle registration and insurance documents.
What should I do if my 2019 AUTOCAR Xpeditor has a recall?
Contact your nearest AUTOCAR dealership immediately to schedule a free recall repair. Bring your vehicle registration or VIN number. All safety recalls must be fixed free of charge by the manufacturer, regardless of vehicle age or mileage.
Are NHTSA recalls mandatory to fix on 2019 AUTOCAR Xpeditor?
While not legally required for vehicle owners to fix recalls, it's strongly recommended for safety. However, dealerships and manufacturers must offer free repairs for all official NHTSA recalls on 2019 AUTOCAR Xpeditor vehicles.
Other Years - AUTOCAR Xpeditor
Other AUTOCAR Models
ACMD Xpert
ACTT Xspotter
ACX Xpeditor
AT
Autocar Ltd
C & DC
Conventional
DC Legend Conventional
DK
K Long
K Medium
K Short
Legend Conventional
Medium Duty On-Highway (XPERT)
S
Terminal Tractor (XSPOTTER) Off-Highway
Terminal Tractor (XSPOTTER) On-Highway
WX
WXLL
WXR
Similar Brands
DONGFENG
3 models
GILLIG
7 models
THOR
20 models
MERCEDES-BENZ
60 models
JAGUAR
17 models
BMW
254 models
TESLA
7 models
HEARTLAND
37 models
KAWASAKI
246 models
LEXUS
17 models