2005 CHEVROLET Aveo Problems & Complaints
Real owner complaints and problems reported to the National Highway Traffic Safety Administration (NHTSA). View common issues by component.
235
Complaints Reported
Complaints by Component
ENGINE AND ENGINE COOLING
50 complaints
TIMING BELT FAILED. DESTROYING THE HEADS AND PISTONS. ..UPDATED 07-05-13 *BF
Jun 10, 2013
THERMOSTAT HOUSING HAS CRACKED DUE TO ITS UNRELIABLE PLASTIC COMPOSITION. AFTER FAILURE, COOLANT WAS LEAKED THROUGHOUT ENGINE COMPARTMENT CREATING A MAJOR FIRE HAZARD AND CAUSING DAMAGE TO MULTIPLE ENGINE COMPONENTS. AFTER RESEARCHING THIS PROBLEM, NUMEROUS COMPLAINTS WERE DISCOVERED WITH THE EXACT NATURE. *KB
Dec 31, 2011
TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT THE TIMING BELT GEAR WAS FRACTURED ON ONE SIDE AND THE OTHER SIDE WAS CLOSE TO FAILING. THE TIMING BELT WAS REPLACED TWICE PRIOR TO THE MOST RECENT FAILURE BY A LOCAL MECHANIC, BUT THE FAILURE RECURRED. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 74,000 AND THE CURRENT MILEAGE WAS 126,096.
Oct 28, 2011
WAS ENROUTE TO WORK IN 2005 CHEVROLET AVEO WHEN THE TIMING GEAR PULLEY BROKE ON THE MOTOR. THE ENGINE WAS DESTROYED AS I FOUND OUT LATER. 5 OR 6 WEEKS EARLIER I HAD JUST HAD THE TIMING BELT REPLACED. I HAD IT REPLACED BEFORE FACTORY RECCOMENDATIONS. MY MECHANIC TOLD ME THEN I NEEDED TO HAVE IT CHANGED. THE BELT DID NOT BREAK TO CAUSE ENGINE FAILURE. A CHEAP PLASTIC PULLEY BROKE INSTEAD. WHEN THE PULLEY BROKE THE TIMING BELT WENT LIMP AND THE ENGINE DECIDED TO DEPOSIT SOME VALVES THROUGH 1 PISTON. THIS TO ME IS A SAFETY CONCERN SINCE IT WAS ALL I COULD DO TO GET THE CAR OFF THE INTERSTATE. CHEVROLET KNOWS ABOUT THESE PROBLEMS AND THEY DONT SEEM TO CARE. I DONT THINK THIS VEHICLE SHOULD BE ALLOWED TO BE SOLD. *TR
Sep 05, 2011
THE PREVIOUS EVENING WE WERE COMING HOME FROM VISITING SOME FRIENDS ,THE CAR WAS NEVER OVER 100 MILES DAY WE BOUGHT IT UNTIL THE TIME OF THE ENGINE'S DEMISE,WE NOTICED A SLIGHT CLICKING NOISE OVER THE MUSIC OF THE RADIO, PULLING INTO A LIGHTED AREA, WE FOUND ALL FLUIDS FINE, NO DRIPPING, NO HEATING UP, NO STALLING, NO REAL INDICATIONS OF ANY TROUBLE EXCEPT A SLIGHT CLICKING.. THE NEXT MORNING I NOTICED A CLICKING AT START UP, IMMEDIATELY I DROVE OFF TO THE REPAIR SHOP THAT WAS JUST BLOCKS AWAY,WHEN I WAS WITHIN 1 BLOCK OF THE SHOP THE ENTIRE SYSTEM SHUT DOWN, WE WERE FORCED TO GET A WRECKER TO TOW US THE LAST BLOCK. THE INDEPENDENT REPAIRMAN INFORMED US THIS WAS A COMMON PROBLEM WITH THIS MAKE OF AUTO (AVEO) DUE TO A DESIGN DEFECT WITH THE TIMING BELT ,IT WOULD DESTROY THE ENGINE AND HE COULD NOT FIND A REPLACEMENT ENGINE. BECAUSE WE HAD 75 THOUSAND MILES ON THE CAR, (AND IT IS PAID OFF) HE THOUGHT HE HAD HEARD OF A RECALL IN 2006,HE SUGGESTED WE CONTACTED THE AUTO DEALER, AUTO WAY CHEVROLET, HWY 19, CLEARWATER, FLA. WHICH WE DID. WE WERE INFORMED BY THEIR SERVICE DIRECTOR THAT THEY COULD NOT FIND AN OPEN 2006 RECALL, THOUGH A REMINDER TO REPLACE BELT AT 68 K, NO ALERT NOR ADVISORY WAS EVER RECEIVED THOUGH WE DO GET ALL ADVERTISEMENTS AND SHE ADVISED AWC DID NOT HANDLE SUCH A PROBLEM, BUT, THEY WOULD GIVE US GM'S NUMBER, UPON CALLING THAT NUMBER I TALKED WITH A VERY AMIABLE YOUNG MAN IN BUENOS AIRES, WHO ALSO INFORMED ME THEY DID NOT APPEAR TO HAVE A RECALL ON THIS PARTICULAR MODEL, HE THEN CALLED AUTO WAY CHEVROLET, CLW. FLA, USA AND MONITORED THE SERVICE DEPARTMENT NOW TELLING ME IF I WOULD BRING IT TO THEM, THEY COULD EVALUATE THE CAUSE AND MAYBE WORK SOMETHING OUT WITH US.. UPON INTERNET INVESTIGATION WE HAVE FOUND A NUMBER OF INDIVIDUALS COMPLAINING ABOUT THIS YEAR,OF AVEO, HAVING THE ENGINE FAIL IN ROUGHLY THE SAME MILEAGE 68-78 THOUSAND MILES. .
Jul 12, 2011
+ 45 more complaints for this component
ELECTRICAL SYSTEM
27 complaints
TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE EXPERIENCED A COMPLETE LOSS OF POWER. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 128,000.
Jan 25, 2016
WHEN I WENT OUT TO START THE VEHICLE I HAD NO DASH BOARD LIGHTS. EVERY OTHER LIGHT SYSTEM WORKED BUT I COULD NOT SEE THE SPEEDOMETER OR THE TACHOMETER. ALL THE FUSES WERE INTACT. I THEN BOUGHT NEW BULBS FOR THE ENTIRE GAGE CLUSTER AND THEY STILL ARE NOT FUNCTIONING. I HAVE LOOKED UP THIS PROBLEM ON MULTIPLE FORUMS AND THIS IS A VERY COMMON ISSUE WITHOUT A SOLUTION OTHER THAN "RIGGING" THIS SYSTEM! THIS IS UNACCEPTABLE PRACTICE TO ALLOW THIS TO GO ON WITHOUT SOME SORT OF RECALL OR REPLACEMENT PART AVAILABLE!
Sep 16, 2015
TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT BURNING WIRES FUMES EMITTED INSIDE THE VEHICLE. THE CONTACT MENTIONED THAT THE KEY RELEASED FROM THE IGNITION WHILE THE VEHICLE WAS ON AND THE RADIO FAILED TO OPERATE INTERMITTENTLY. IN ADDITION, THE HEADLIGHT MALFUNCTIONED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 95,000.
Nov 24, 2014
TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT THE INSTRUMENT PANEL LIGHTING, BRAKE LIGHTS, AND LICENSE PLATE LIGHTS FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC. THE CONTACT WAS INFORMED THAT THE WIRING CONNECTED TO THE FUSE BOX UNDER THE HOOD WAS MELTED AND BURNED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 104,802. UPDATED 9/4/14*CN
Jul 23, 2014
TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT THE HEADLIGHT LIGHTS, THE PARKING LIGHTS, AND DAYTIME LIGHTS FAILED TO ILLUMINATE. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSE THAT THE MAIN FUSE BOX AND WIRING HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000. UPDATED 9/18/14*CN UPDATED 02/05/2015 *JS
Jul 21, 2014
+ 22 more complaints for this component
ELECTRICAL SYSTEM,EXTERIOR LIGHTING
24 complaints
TACADA RECALL I BOUGHT MY CAR HAD 121000 MILES ALL A SUDDEN I HAVE NO RIGHT TAIL LIGHT NO DASH LIGHTS AN NO PASSENGERS FRONT ORANGE LIGHT THER IS NO POWER GOING TO FUSE BOX UNDER HOOD I CALLED THE DEALERSHIP THEY STATED MY VIN HAD BEEN FIXED FOR THAT RECAL AND IT HAS NOT
Jul 06, 2019
GM MUST NOT KNOW THIS THIS HAS TO DO WITH THE ELECTRICAL WIRE HARNESS INSIDE OF THE ENGINE BLOCK FOR THE LIGHTS. FOR SOME REASON THE POWER IS OVER WRITING THE FUSES AND NOT BLOWING AND CAUSING SMALL ENGINE FIRES THAT COULD GET OUT OF CONTROL. I CAUGHT MINE IN ENOUGH TIME AND PUT IT OUT. A GUY HAS TO DO WITH THE RIGHT SIDE AND THE LEFT SIDE IN THE FUSE BOX BEING TWO SEPARATE ENTITIES OF WIRES WHICH IS 7 + 7 EQUALS 14 TO CONTROL TWO DIFFERENT SIZES. I WAS JUST WONDERING WHY AND GM NEEDS TO KNOW WHAT'S THE SENSE OF HAVING A FUSE BOX IF THE WIRES ARE GOING TO OVERRIDE THE FUSE. AND POSSIBLY CATCH FIRE OR WILL CATCH FIRE IT JUST A MATTER OF AN ACCIDENT WAITING TO HAPPEN. I'VE BEEN ON YOUTUBE AND FOUND OUT THIS IS A COMMON THING TO HAPPEN FOR CHEVY AVEO WILL THERE BE A 2004 THROUGH 2008. I'M LETTING YOU KNOW ABOUT THIS CONCERN BECAUSE I DO NOT WANT ANYBODY TO DIE FROM A CAR FIRE BECAUSE GM.MAYBE NOT KNOW ABOUT THIS THAT IT'S A BIG ISSUE AN ACCIDENT WAITING TO HAPPEN. SINCERELY [XXX] IF SOMEONE NEEDS TO REACH ME MY PHONE NUMBER IS +[XXX]. THANK YOU N.T.S.B FOR LOOKING INTO THIS. JUST REALLY CONCERNED BECAUSE IF THE FIRE WOULD HAVE GOT OUT OF HAND I HAVE MY GRANDCHILDREN IN THE CAR GOD FORBID SOMETHING WERE TO HAPPEN TO THEM. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *CC *TR
Nov 20, 2018
INTERIOR DASH AND CONSOLE LIGHTS IN-OPERATIVE AS WELL AS THE RIGHT TAIL LIGHT. JESUS CHRIST, AFTER SEEING ALL OF THE PEOPLE COMPLAINING ABOUT THIS OUR BELOVED NO GOOD FOR NOTHING GOVERNMENTAL AGENCIES SHOULD MAKE GM RESPONSIBLE FOR THE COST OF REPAIR FOR THIS OBVIOUS MANUFACTURERS OR ENGINEERING DEFECT. OR AT LEAST SEND OUT DETAILED INSTRUCTIONS TO THE OWNERS ON HOW TO FIX THIS PROBLEM SO THEY CAN TAKE IT TO THEIR MECHANIC OF CHOICE TO GET IT FIXED. THE DEALERS OBVIOUSLY DON'T WANT TO DO ANYTHING ABOUT IT. AND THEY CHARGE TOO MUCH ANY HOW. SINCERELY, GEORGE S.
Nov 26, 2016
TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT THE HEADLIGHTS FAILED. THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT THE WIRING HARNESS CONNECTORS SHORTED DUE TO OVERHEATING, WHICH BURNED AND MELTED THE WIRES. THE DEALER ADVISED THAT NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING) WOULD ONLY REPAIR THE DRL MODULE AND IT WOULD NOT REPLACE ANY ADDITIONAL FAILURE CAUSED BY THE RECALL. THE CONTACT ALSO STATED THAT THE ENGINE VALVE COVER GASKET WAS DEFECTIVE AND CAUSED THE ENGINE FLUID TO LEAK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000.
May 01, 2015
I BOUGHT THIS CAR FOR IN 2011 WITH 25,000 MILES, FIRST 6 MONTHS WAS GREAT. BUT THEN THE INSIDE PANEL LIGHTS WERE GOING ON AND OFF. DOOR LOCKS WEREN'T WORKING AND I NOTICED A BURN MARK ON MY PANEL UNDER STEERING WHEELS AND TOOK TO A SHOP AND HE SAID WIRES WERE A MESS UNDER THE DASH. HE FIXED THE DOOR LOCKS FOR ME AND 200 AND SOMETHING DOLLARS STILL NO PANEL LIGHTS. I TRIED TO FIX THIS PROBLEM BUT NO ONE WANTS TO TOUCH THE MESS. I GOT A RECALL FOR THE DAYTIME RUNNING LIGHTS WHICH I NEVER HAD A PROBLEM WITH, SO WHEN I BROUGHT IT IN FOR THAT TOLD THEM ABOUT THE PROBLEM AND NOTHING WAS DONE. *TR
Mar 11, 2015
+ 19 more complaints for this component
EXTERIOR LIGHTING
15 complaints
The contact's daughter owns a 2005 Chevrolet Aveo. The contact stated that intermittently, the headlights failed to illuminate. The contact's daughter had received notification of NHTSA Campaign Number: 14V261000 (Exterior Lighting). The contact made a local dealer aware of the failure and the recall; however, the dealer informed the contact that parts were on backorder. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 60,000.
May 09, 2023
TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT THE DAYTIME RUNNING LIGHTS FAILED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING). THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS REPAIRED UNDER THE RECALL REMEDY HOWEVER IT FAILED TO REPAIR THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 70,000.
Aug 18, 2015
TL*THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT ALL INTERIOR LIGHTS AND THE INSTRUMENT PANEL LIGHTS FAILED TO ILLUMINATE. AS A RESULT, THE CONTACT WAS UNABLE TO READ THE GAUGES AND THE DRIVER SIDE TAIL LIGHT FAILED TO ILLUMINATE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 108,000.
Feb 24, 2015
TL*THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING). HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 7/23/15*CN UPDATED 10/01/15*LJ MA 10/14/15 UPDATED 9/21/2017*CN
Feb 06, 2015
TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING) HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Jan 09, 2015
+ 10 more complaints for this component
ENGINE
11 complaints
The contact owns a 2005 Chevrolet Aveo. The contact stated while driving 45 MPH and making a stop, the vehicle inadvertently lost motive power. The contact was unable to restart the vehicle after several attempts. The contact was able to push the vehicle to the nearby gas station with assistance. The contact refilled the coolant reservoir and was able to restart the vehicle. The vehicle was taken to the independent mechanic who diagnosed that the vehicle had overheated, and the valve cover gasket needed to be replaced. The vehicle was not repaired however, the valve cover gasket was sealed. The dealer and the manufacturer were not notified of the failure. The vehicle was not repaired. The approximate failure mileage was 140,000.
Oct 08, 2021
Timing belt/chain broke. Car is below the 60,000 mile mark for scheduled replacement as stated from manufacturer. Car broke down suddenly in the middle of the road creating a hazard to the driver and others.
Aug 28, 2021
I BOUGHT THIS CAR BRAND NEW AND KEPT UP THE MAINTENANCE RELIGIOUSLY! I WAS HORRIFIED TO FIND OUT THAT MY TIMING BELT WENT OUT AT 46,000 MILES! MY MANUAL SAYS TO REPLACE TIMING BELT AT 60,000 MILES. I'VE READ THERE WAS A RECALL ISSUED IN 2006, BUT IT DIDN'T GO TO OWNERS; JUST SERVICE SHOPS...I WAS NEVER ALERTED, THAT WAS DEFINITELY A MISTAKE ON GM'S PART. I FEEL AS THOUGH I SHOULD BE COMPENSATED!!!
Dec 27, 2016
TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. WHILE DRIVING 25 MPH, THE VEHICLE STALLED WITHOUT WARNING. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO STATED THAT THE TIMING BELT, ENGINE, AND VALVES WERE MELTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 53,000.
Oct 07, 2016
THE MILEAGE AND SPEED ARE APPROXIMATE. I WAS BACKING OUT OF MY ICE AND SNOW COVERED DRIVEWAY IN FEBRUARY 2015. THERE IS A SMALL DIP WHERE MY DRIVEWAY MEETS THE STREET SO I ACCELERATED SO AS NOT TO GET MY TIRES STUCK IN THE ICY DIP. AS I WAS BACKING MY CAR INTO THE STREET, AND MY CAR WAS IN THE LANE OF TRAFFIC THE CAR SHUT OFF. I WAS UNABLE TO RESTART THE CAR. MY NEIGHBOR, AND ANOTHER GENTLEMAN WHO STOPPED TO HELP, PUSHED MY CAR BACK INTO MY DRIVEWAY. I ATTEMPTED TO START THE CAR SEVERAL TIMES AFTER THE INCIDENT. THE CAR NEVER AGAIN STARTED. I BORROWED A VEHICLE UNTIL I HAD ENOUGH MONEY TO HAVE THE CAR TOWED TO A MECHANIC FOR REPAIRS. A MECHANIC LOOKED AT MY VEHICLE AND TOLD ME ON MAY 11, 2015 THAT THE CAR NEEDS A NEW ENGINE, THE PRICE OF WHICH IS $4,823.00. THE MECHANIC FURTHER TOLD ME THAT THE AFTERMARKET/REMANUFACTURED ENGINES COMPANY THEY DEAL WITH DOES NOT HAVE AN ENGINE FOR THIS MAKE AND MODEL CAR BECAUSE THIS ENGINE HAS SO MANY PROBLEMS THAT THE COMPANY WILL NOT TOUCH IT. I BELIEVE THAT THE OEM ENGINE HAS SERIOUS DEFECTS THAT HAVE BEEN OVERLOOKED DUE TO THE LACK OF REPORTING AND LACK OF SERIOUS INJURY ASSOCIATED WITH THE DEFECT/FAILURE. MY CAR HAS SHUT OFF ON ME ON THREE DIFFERENT DAYS WITHIN AN APPROXIMATE SIX MONTH PERIOD. I HAD A MECHANIC LOOK AT THE CAR TO FIGURE OUT WHY IT WAS SHUTTING OFF ON ME IN TRAFFIC AND THERE WAS NO INDICATOR OF ANY ISSUE. MY CHECK ENGINE LIGHT NEVER CAME ON, EVEN AFTER THE RECENT ENGINE FAILURE. PLEASE INVESTIGATE THIS ENGINE. *TR
May 13, 2015
+ 6 more complaints for this component
AIR BAGS
10 complaints
AIR BAG FAULT INDICATOR HAS COME ON AND REMAINS ON. MECHANIC CAN NOT DIAGNOSE TO REPAIR. AIRBAGS ARE CRITICAL TO THE SAFETY OF PERSONS IN THIS SMALL LIGHTWEIGHT VEHICLE. NORMAL DRIVING, COMMUTER.
Aug 21, 2016
I WAS TRAVELING NORTH UNDER AN OVERPASS WHEN MY LIGHT TURNED GREEN AND A CAR COMING OFF THE HWY HEADING WEST RAN THE STOP LIGHT. I HIT THE BRAKES WHEN I SAW HER BUT IT WAS TOO LATE AND SHE WAS GOING TOO FAST. THE FRONT BUMPER ON THE 2005 CHEVROLET AVEO I WAS DRIVING HIT HER CAR ON THE DRIVERS SIDE AFT QUARTER PANEL. THE IMPACT SPUN HER CAR ALL THE WAY AROUND AND I JUST ROLLED TO A STOP. I GOT OUT TO GO TALK TO HER AND SHE DROVE OFF. I GOT BACK IN MY CAR AND FOLLOWED HER. WHEN I CAUGHT UP TO HER, SHE WAS A NERVOUS WRECK. I TALKED HER INTO FOLLOWING ME ACROSS THE STREET TO A CIRCLE K GAS STATION AND WAITED FOR POLICE. SHE WAS DRIVING A 2005, I THINK, LEXUS 330, AGAIN I THINK. THE BAD THING WAS NEITHER ONE OF OUR CARS AIRBAGS DEPLOYED. HER CAR MIGHT BE CORRECT BUT ALL MY DAMAGE WAS STRAIGHT IN THE FRONT ON THE BUMPER AND THE HOOD HAS SOME MINOR DAMAGE BUT THE FRONT BUMPER IS TRASHED. I WAS WEARING MY SEATBELT BUT I DID INJURE MY BACK AND MY STOMACH AREA. I HAVE NOT BEEN TO THE DOCTOR YET AS I AM WAITING TO MAKE SURE I'M NOT JUST SORE FROM THE IMPACT. *TR
Dec 02, 2011
I WAS PASSING THROUGH AN INTERSECTION IN A 2005 CHEVY AVEO, I WAS HIT HEAD ON BY A FORD RANGER PICKUP TRUCK, BOTH VEHICLES WERE TOTALED. THE OTHER DRIVERS AIRBAG HAD GONE OFF BUT MINE DID NOT. AS A RESULT HE WAS FINE, BUT I WAS KNOCKED TEMPORARILY UNCONSCIOUS. I SPENT THE REST OF THAT DAY IN A HOSPITAL GETTING X-RAYS DONE AND WAS LAID UP IN BED FOR THE NEXT WEEK ON PAIN KILLERS AND MUSCLE RELAXERS. THE PAIN (PRIMARILY IN MY NECK, UPPER BACK, AND MY HEAD WHICH HIT THE STEERING WHEEL) HAS STILL YET TO GO AWAY NOW ALMOST 3 WEEKS LATER. *TR
Jan 10, 2011
WHILE TRAVELING TO A DOCTOR APPOINTMENT AT APPROXIMATELY 2:30 PM ON 11/18/09, I HYDROPLANED ON THE WET INTERSTATE I 40 EAST, NEAR EXIT 37, SLID SIDEWAYS AT A 90' ANGLE TO OUTSIDE LANE OF I 40 EAST, ATTEMPTED TO COUNTERSTEER INTO THE SLIDE, WHICH CAUSED MY VEHICLE TO SPIN 360' AND STRIKE THE CONCRETE LANE DIVIDER HEAD ON AT 40 OR 45 MPH. THE VEHICLES AIR BAGS DID NOT DEPLOY, AND I PROBABLY SUSTAINED A GREATER CHEST CONTUSION TO MY STERNUM DUE TO SEAT BELT RESTRAINT IMPACT TO MY CHEST. THIS HAS ALSO CAUSED AN INCREASE TO BACK PAIN DUE TO A PRIOR PROBLEM OF 3 FUSED VERTEBRAE IN MY UPPER SPINE AND PROBABLY A FRACTURED STERNUM, BUT X-RAYS ARE NOT CONCLUSIVE. I CAN NOT HELP BUT THINK HAD THE AIRBAGS DEPLOYED I WOULD NOT HAVE SUSTAINED SUCH A SEVERE BLOW TO MY CHEST AND WOULD NOT HAVE BEEN INJURED NEARLY AS BAD AS I HAVE BEEN. I BELIEVE THE AIR BAG SYSTEM MALFUNCTIONED AS THE CAR WAS A TOTAL LOSS, AND THE IMPACT KNOCKED ME UNCONSCIOUS FOR ABOUT 15 SECONDS. I REMEMBER THE BACK WHEELS OF THE VEHICLE FLYING UP INTO THE AIR, AND THE REAR END BOUNCING BACK TO THE GROUND. *TR
Nov 27, 2009
TL*THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE AIR BAG LIGHT REMAINS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES, BUT THEY WERE UNABLE TO LOCATE THE EXACT CAUSE OF THE FAILURE. THE DEALER REPLACED THE AIR BAG SENSOR AND THE WIRING UNDER THE FRONT PASSENGER SEAT, BUT THIS DID NOT CORRECT THE FAILURE. THE CURRENT MILEAGE WAS 15,239 AND FAILURE MILEAGE WAS 6,753.
Apr 16, 2008
+ 5 more complaints for this component
LATCHES/LOCKS/LINKAGES
8 complaints
2005 CHEVROLET AVEO. CONSUMER WRITES IN REGARDS TO VEHICLE HOOD LATCH STICKING OR NOT WORK AT ALL, WHEN ITS COLD. *SMD
Mar 18, 2015
TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT AFTER EXITING THE VEHICLE, THE DOOR LOCKS FAILED TO LOCK. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS BUT THE DEALER ADVISED AGAINST REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 43,500. THE VIN WAS NOT AVAILABLE. *TR
May 29, 2013
2005 CHEVY AVEO, BOTH OF THE INSIDE DOOR LATCHES BROKE. THEY SEEM TO BE MADE OF PLASTIC AND BROKE VERY EASY. *TR ## VIN FAILED ##
Mar 13, 2013
THIS MORNING I WALKED OUT TO MY CAR AND FOUND THE LOCK TO MY CAR WAS PUNCHED INTO THE DRIVER SIDE DOOR. *TR
Jun 30, 2010
THE LOCKING MECHANISM ON MY 2005 CHEVROLET AVEO HAS BEEN GETTING STUCK. IT DOES NOT OPEN MANUALLY, IT WILL NOT UNLOCK WITH THE KEY INSERTED ON THE DOOR, NOR WILL IT UNLOCK WHEN I AM INSIDE THE VEHICLE. THE ONLY WAY TO OPEN MY DOOR IS WITH THE REMOTE. I FEAR THAT IN THE EVENT OF AN EMERGENCY I WILL NOT BE ABLE TO EXIT MY VEHICLE IN TIME. THERE IS ALSO THE FEAR THAT I MAY BECOME STRANDED BECAUSE THE BATTERIES IN THE REMOTE HAS DIED AND I WILL BE UNABLE TO OPEN THE DOOR EVEN THOUGH I HAVE MY KEYS. *TR
Mar 02, 2010
+ 3 more complaints for this component
VEHICLE SPEED CONTROL
8 complaints
2005 CHEVY AVEO I BELIEVE MY ACCELERATOR BECAME "STUCK" WHILE DRIVING ON THE INTERSTATE - CANNOT CONFIRM BUT WHEN I WAS EXITING, IT WAS EXTREMELY DIFFICULT TO STOP AND WAS REDLINING WHILE AT A STOP. I TURNED THE CORNER AND THE CAR ACCELERATED UP TO 50 WITH NO FOOT ON THE ACCELERATOR NOR ON THE BRAKE. (50 WAS AS I WOULD "LET IT" GO). I WAS ABLE TO MAKE IT HOME, BUT REDLINED AGAIN WHEN I PUT IT IN PARK. WAS TO TAKE IT IN, REDLINED IMMEDIATELY AT IGNITION. MY DAD SLAMMED ON THE ACCELERATOR PEDAL AND IT STOPPED. HE DROVE IT TO THE MECHANIC, AND SAID IT DROVE "FINE." THE MECHANIC WAS UNABLE TO RECREATE THE SCENARIO AND SAID THE COMPUTER DID NOT REGISTER A PROBLEM AND THEREFORE THEY ARE UNABLE TO FIX ANYTHING UNTIL IT HAPPENS AGAIN OR GETS WORSE. DROVE THE CAR ON SHORT DISTANCES AGAIN FOR LESS THAN A WEEK. AT THAT TIME, THE BATTERY LIGHT CAME ON AND STEERING WAS HORRIBLE - (POWER STEERING OUT?) MADE IT LESS THAN 10 MILES HOME, WHEN THE CAR DIED. WOULD NOT TURN ON, MADE CLICKING NOISE. TRIED CHARGING THE BATTERY, WAS ABLE TO MAKE IT TO THE MECHANIC AGAIN...WHERE THEY SAID A BELT HAD FAILED. IT'S THE BELT THAT AFFECTED THE ALTERNATOR'S ABILITY TO CHARGE THE BATTERY AND THE POWER STEERING. THERE IS ALSO A TRANSISTOR THAT WENT BAD. RELATIVELY CHEAP TO FIX, BUT I HAD MY 1 YEAR OLD SON IN THE CAR WHEN THE CAR WAS ACCELERATING ON IT'S OWN. NOT SAFE! OTHER THAN THAT, I HAVE NOT HAD A SINGLE PROBLEM WITH MY AVEO. *TR
Mar 16, 2010
TL* THE CONTACT OWNED A 2005 CHEVROLET AVEO. WHILE PULLING INTO A PARKING SPACE SHE NOTICED THERE WAS A SUDDEN INCREASE IN ENGINE RPMS. THE ENGINE ROARED LOUDLY AND IMMEDIATELY, THE VEHICLE ABNORMALLY ACCELERATED AT A RAPID RATE OF SPEED, CRASHING FRONT END INTO A VEHICLE TO HER RIGHT. THE VEHICLE BOUNCED BACK AT THE IMPACT AND SWERVED TO THE LEFT, CRASHING INTO A JEEP. THE VEHICLE DID NOT STOP DESPITE THE CONTACTS SEVERAL ATTEMPTS TO DEPRESS THE BRAKE PEDAL. THE BRAKES WOULD NOT RESPOND AND THE CONTACT WAS THRUST BACK INTO HER SEAT. SHE CONTINUED TO DEPRESS THE BRAKES UNTIL FINALLY THE VEHICLE SLOWLY COASTED TO A STOP. THERE WERE NO INJURIES, HOWEVER THE VEHICLE WAS DECLARED AS DESTROYED BY HER INSURANCE COMPANY. THE FAILURE MILEAGE WAS APPROXIMATELY 4,029. UPDATED 4/30/10 *CN UPDATED 09/16/10
Mar 11, 2010
TL*THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT AS SHE WAS DRIVING 5 MPH INTO A PARKING SPACE THE VEHICLE ACCELERATED AND CRASHED INTO A FENCE, A DRIVEWAY AND THEN STOPPED ON A PORCH. NO ONE WAS INJURED. THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS AVAILABLE IF NEEDED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 54,000.
Feb 17, 2010
MY 2005 CHEVY AVEO RPM'S STICK AND WILL NOT BE FORCED DOWN BY DE-ACCELERATION OR HITTING THE BRAKE. THIS HAS BEEN OCCURRING ON AN IRREGULAR BASIS SINCE PURCHASE (AUGUST 2005). I HAVE HAD THE CAR BACK TO THE CHEVY DEALER AT LEAST 5 TIMES FOR THE SAME REASON IN ADDITION TO OTHER TIMES WHEN THE DASH BOARD LIGHT WARNINGS COME ON. THE DEALER CAN NOT RECREATE OR FIX. THE DASH BOARD LIGHT DID COME ON BACK IN JUNE 07 RE: ELECTRICAL AND THE FIX TO THE ELECTRICAL ISSUE DID FOR A FEW MONTHS FIX THE RPM STICKING. HOWEVER THE INTERMITTENT RPM STICKING HAS RETURNED (JAN 2008). THE RPM'S STICK USUALLY BETWEEN 35 TO 65 MPH AND IN ANY TYPE OF WEATHER. USUALLY WHEN JUST STARTING HOME FROM WORK OR ON HIGHWAY DRIVING. *TR
Jan 30, 2008
TL*THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT WAS AT A STOP SIGN WITH THE BRAKE AND ACCELERATOR PEDAL ENGAGED. THE VEHICLE SPEED CONTROL SWITCH WAS REPLACED PREVIOUSLY. THE MANUFACTURER ADVISED THE CONTACT TO TRY ANOTHER DEALER. THE DEALER TEST DROVE THE VEHICLE AND STATED THAT IT WAS OPERATING NORMALLY. THE CURRENT MILEAGE WAS 17,873 AND THE FAILURE MILEAGE WAS 3,000. UPDATED 02-14-08. *KB THE CONSUMER STATED THE SPEED CONTROL SWITCH WAS REPALCED. UPDATED
Jan 09, 2008
+ 3 more complaints for this component
POWER TRAIN
6 complaints
TL*THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT WHILE TRYING TO REVERSE, THE LEVER WAS SHIFTED INTO REVERSE BUT THE VEHICLE FAILED TO MOVE. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC. THE TECHNICIAN WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 14,321.
Jan 28, 2015
2005 CHEVY AVEO WILL NOT SHIFT OUT OF PARK. THE VEHICLE HAS BEEN IN THE SHOP SEVERAL TIMES AND THE PROBLEM IS STILL OCCURRING FOUR YEARS LATER. *TR
Jul 07, 2009
I HAVE A 2005 CHEVY AVEO THAT HAS REPEAT PROBLEMS WITH THE CLUTCH GETTING HOT AND SEIZING THE TRANSMISSION, I HAD THIS FIXED ONE IN JUNE OF THIS YEAR AND TODAY THE CLUTCH IS DOING THE SAME THING AGAIN, THIS TIME I ALMOST GOT IN 2 ACCIDENTS, COULDN'T SHIFT RIGHT AND WAS UNSAFE TO DRIVE. *TR
Oct 09, 2008
MY CLUTCH LET GO IN MY CAR, I WAS TOLD BY THE MECHANIC THAT THE CLUTCH GOT TOO HOT AND CRACKED THE PLATE AND THE FLYWHEEL, IT WAS NOT SUPPOSED TO DO THAT, THE CAR WAS HAVING TROUBLE SHIFTING AND I COULD OF BEEN HURT. *TR
Jul 06, 2008
2005 CHEVY AVEO CLUTCH DEFECT. *TR
May 30, 2008
+ 1 more complaint for this component
SERVICE BRAKES, HYDRAULIC
6 complaints
2005 CHEVROLET AVEO REAR BRAKES 70,000 MILES SHOE CAME UNGLUED CAUSING 87 YEAR OLD MAN TO GO IN DITCH DEEP SNOW AT 15 BELOW ZERO. *TR
Jan 18, 2011
WHILE PULLING OUT OF PARKING SPACES (USUALLY), THE BRAKE WILL NOT GO DOWN. I HAVE TO PUSH THE PEDAL WITH ALL MY STRENGTH TO GET THE CAR TO STOP. LUCKILY IT ALWAYS HAPPENS IN PARKING LOTS SO THE CAR IS ONLY GOING 5MPH AT THE HIGHEST. THE DEALERSHIP SAID THAT THE BRAKE LINE HAD A LEAK IN IT. THEY REPLACED THE LINE, BUT THE PROBLEM STILL OCCURS AT LEAST ONCE A WEEK. I HAD THEM LOOK AT IT A SECOND TIME AND THEY SAID THAT THEIR MACHINES WEREN'T SHOWING ANY TYPE OF WARNING ABOUT THE PROBLEM. *TR
Sep 05, 2010
TL*THE CONTACT OWNS A 2005 CHEVROLET AVEO. WHILE DRIVING APPROXIMATELY 50 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL. THE VEHICLE FAILED TO SLOW DOWN. AFTER SEVERAL ATTEMPTS, THE VEHICLE CAME TO A COMPLETE STOP. THERE WERE NO WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY STATED THAT THE VEHICLE WAS PERFORMING AS NORMAL. ON A SEPARATE OCCASION, THE ROTORS, BRAKE PADS, BRAKE SHOES, AND BRAKE DRUMS WERE REPLACED. THE FAILURE MILEAGE WAS 26,400 AND CURRENT MILEAGE WAS 64,500. UPDATED 10/16/08. *LJ THE CONSUMER STATED THE BRAKES WIL STOP THE VEHICLE, BUT THE TRAEEL IN THE PEDAL WAS THE ISSUE. THE BRAKE PEDAL TRAVELLED ALMOST 3 INCHES BEFORE THE BRAKES EVEN BEGAN TO SLOW THE VEHICLE DOWN. THE BRAKES WOULD THEN SLOW THE CAR. THE CONSUMER STATED HE HAD SPOKEN TO OTHER DEALERS WHO STATED THE ISSUE WAS BETWEEN THE BRAKE PEDAL AND THE BRAKE BOOSTER. UPDATED 10/17/08. *JB
Aug 07, 2008
DT*: THE CONTACT STATED THAT THE BRAKE PEDAL WAS MUSHY, AND WHEN IT WAS DEPRESSED, LOWERED TO THE SAME POINT AS THE ACCELERATOR PEDAL. THIS CAUSED THE CONTACT TO ACCIDENTALLY APPLY PRESSURE ON BOTH PEDALS. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE DEALER NOTED THAT THE REAR CALIPERS WERE NOT ADJUSTING. THE DEALER LUBRICATED AND ADJUSTED THE CALIPERS, WHICH DID NOT COMPLETELY FIX THE PROBLEM. UPDATED 8/16/2006 - *NM
Jul 26, 2006
DT*: THE CONTACT STATED WHILE THE BRAKE PEDAL WAS DEPRESSED, THE VEHICLE SHOOK. THE DEALERSHIP REPLACED THE REAR DRUMS THREE TIMES, RESURFACED THE REAR DRUMS, AND REPLACED THE BRAKE SYSTEM. THESE EFFORTS HAVE NOT CORRECTED THE SHAKING PROBLEM. UPDATED 05/16/2006.*AK *NM
Apr 21, 2006
+ 1 more complaint for this component
VISIBILITY
5 complaints
CRACK DEVELOPED IN THE UPPER LEFT OF WINDSHIELD WAS NOT CAUSED BY A STONE OR ANYTHING ELSE. DEALERSHIP IS SAYING IT WAS CAUSED BY THE WINDSHIELD WIPER. IT STARTED BEYOND THE WIPER RANGE. *TR
Sep 16, 2008
I HAVE TAKEN MY CAR IN SEVERAL TIMES TO SEE WHY THERE IS SUCH A BAD SHAKING WHEN I REACH SPEEDS IN EXCESS OF 55 MPH AND THERE SEEMS TO BE NO REASON AFTER BALANCING MY TIRES, ON TOP OF HAVING ALL REPLACED AND ALLINING THE TIRES THERE IS A HORRIBLE SHAKING OF THE STEERING WHEEL AND A VERY LOUD NOISE LIKE A ROARING OISE IN THE BACK OF MY CAR. ALSO I HAVE A HUGE CRACK IN THE WINDSHILED THAT I THOUGHT CAME FROM A PEPPLE OR SOMETHING HITTING THE WINDSHIELD HOWEVER THERE IS NOT A DENT SO TO SPEAK OR ANY MARKS THAT WOULD INDICATE A ROCK HIT IT, THE CRACK STARTS UDER TEH RUBBER LINING AND GOES ALL THE WAY DOWN THE WINDSHIELD FROM ONE END TO THE OTHER. FB
Jun 24, 2007
SUMMER 2005 THE DRIVER'S SIDE WINDSHIELD WIPER STOPPED WORKING DURING A RAINSTORM WHILE OPERATING THE VEHICLE LEAVING MY VISIBILITY EXTREMELY IMPAIRED. UPON SUBSEQUENT EXAMINATION, I NOTICED THAT THE NUT HOLDING THE WIPER TO THE POST HAD LOOSENED AND BACKED OFF. THIS STRIPPED THE MATING GROVES OFF BOTH THE WIPER ARM (CAST ALUMINUM) AND POST (SOFT METAL). EVEN AFTER RE-TIGHTENING THE NUT, THE WIPER WAS UNABLE TO MOVE BECAUSE THE WIPER ARM AND POST WERE TOO BADLY DAMAGED; ALL OF THE GROVES WERE ENTIRELY REMOVED FOR THE CAST ALUMINUM WIPER ARM. I WAS UNABLE TO GO TO A DEALER TO HAVE THIS REPAIRED. I DRILLED A KEYWAY INTO BOTH THE WIPER ARM AND POST. I FILLED THE KEYWAY WITH A PORTION OF A LARGE PAPER CLIP. THE DAMAGE REMAINS THIS WAY CURRENTLY. SUMMER 2005 HAVING EXPERIENCED THE PROBLEM WITH THE AVEO 2004 (ABOVE) I TIGHTENED THE NUTS ON BOTH THE PASSENGER AND DRIVER'S WIPERS ON MY AVEO 2005. JANUARY 2007 THE DRIVER'S SIDE WINDSHIELD WIPER STOPPED WORKING DURING A SNOWSTORM WHILE OPERATING VEHICLE LEAVING MY WIFE'S VISIBILITY EXTREMELY IMPAIRED. UPON SUBSEQUENT EXAMINATION, I NOTICED THAT THE NUT HOLDING THE WIPER TO THE POST HAD LOOSENED AND BACKED OFF EVEN WITH RE-TIGHTENING THIS NUT IN THE SUMMER OF 2005. THIS STRIPPED THE MATING GROVES OFF BOTH THE WIPER ARM (CAST ALUMINUM) AND POST (SOFT METAL). I HAVE TAKEN THIS CAR TO THE DEALER TO HAVE BOTH THE WIPER ARM AND POST REPLACED. I AM CURRENTLY WAITING ON PARTS TO HAVE TO REPAIR MADE.--AFTER SEARCHING THE WEB I DISCOVERED THAT SOMEONE ELSE HAD A PROBLEM WITH THEIR DRIVER'S SIDE WIPER ARM NUT COMING LOOSE. HTTP://WWW.EPINIONS.COM/CONTENT_160219565700. *JB
Jan 29, 2007
DT: THE CONTACT STATED THE FRONT WINDSHIELD FOGGED UP. THIS OCCURRED WITH THE DEFROSTER ON. THE DEALERSHIP WAS UNABLE TO MAKE A DIAGNOSIS. THE MANUFACTURER STATED WITHOUT A DIAGNOSIS THEY WERE UNABLE TO OFFER ANY ASSISTANCE. *AK
Dec 22, 2005
MY 2005 CHEVY AVEO HAS 2500 MILES ON IT AND I HAVE HAD TO REPLACE THE FRONT WIPERS ALREADY AND HAVE HAD THE CAR FOR LESS THAN 1 MONTH. THE FRONT WIPERS ALSO HAVE A BAD TIME WITH MAKING A CLICKING SOUND TO WHICH I HAVE SMELT A BURNING SMELL UNDER THE DASH ONLY WHEN THE WIPERS ARE ON. THIS HAS MADE IT HARD TO SEE ON THE HIGHWAY AND ALMOST CAUSED A WRECK WHEN I SMELT A SMOKE SMELL.*JB
Feb 20, 2005
SUSPENSION
4 complaints
TL*THE CONTACT OWNS A 2005 CHEVROLET AVEO. AFTER THE VEHICLE WAS TAKEN IN FOR SERVICE, IT BEGAN MAKING A LOT OF NOISE. THE CONTACT RETURNED THE VEHICLE TO THE DEALER, BUT THEY COULD NOT DETERMINE THE CAUSE OF THE FAILURE. HOWEVER, THEY DISCOVERED A SCREW GLUED TO THE FRONT SUSPENSION. THE CONTACT TOOK THE VEHICLE TO ANOTHER REPAIR SHOP AND THEY STATED THAT THERE WAS A WEAK STRUT MOUNT IN THE FRONT SUSPENSION. THE CONTACT CONTINUED TO TAKE THE VEHICLE BACK AND FORTH TO THE DEALER BECAUSE THE BOLT COULD HAVE LOOSENED AND CAUSED A CRASH. THE DEALER FINALLY INSPECTED THE VEHICLE AND REORDERED THE PARTS FOR THE REPAIR. THE FAILURE MILEAGE WAS 41,000. UPDATED 1/6/09 *CN THE CONSUMER WAS TOLD A MAIN CONNECTION POINT BOLT ON THE CROSSMEMBER WAS STRIPPED AND VERY LOOSE. UPDATED 01/14/09. *JB
Dec 12, 2008
MY AVEO IS 2005 AND MY REAR DRIVER SIDE SHOCK HAD THE TOP BOLT HOLDING THE SHOCK TO THE CAR SNAP. *TR
Sep 14, 2008
EVERY FEW THOUSAND MILES I HAVE TO GET MY CAR REALIGNED. THIS PROBLEM IS COSTING ME IN FEES AND NEW TIRES. *TR
Sep 02, 2008
I BOUGHT THE 05 AVEO ON NOV 15, 2006, I HAVE EXPERIENCED FRONT END SHAKING AT SPEEDS OF 50, THE DEALERSHIP REPLACED THE ENGINE AND TRANSMISSION MOUNTS. THE PROBLEM IS BETTER BUT STILL THERE. ALSO HAVE HAD FRONT END NOISE LIKE CREEKS OVER BUMPS AND MAKING TURNS, THE DEALERSHIP REPLACED THE BUSHINGS, THE NOISE WENT AWAY FOR A COUPLE OF DAYS BUT CAME BACK TWICE AS BAD, TOOK THE CAR BACK TO THE DEALERSHIP NOW AM WAITING FOR NEW BUSHINGS TO BE ORDERED."WITH THE HOPES THAT IT WILL END THE PROBLEM" AS PER SERVICE MANAGER. *JB
Jan 17, 2007
VEHICLE SPEED CONTROL,ENGINE
3 complaints
TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT WHEN ATTEMPTING TO ACCELERATE FROM A STOP, THE ENGINE RPMS ABNORMALLY INCREASED WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO DEALER FOR A DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 70,000. THE CONSUMER STATED THE ACCELERATOR PEDAL BECAME STUCK. SHE TRIED TO RELEASE IT WITH HER HAND, BUT IT DIDN'T MOVE. UPDATED 11/18/14
May 21, 2014
MY WIFE WAS DRIVING OUR CHEVY AVEO 2005 ON A MAJOR 4 LANE HIGHWAY DURING THE MORNING RUSH HOUR. SHE IS DOING ABOUT 60MPH IN THE INNER LEFT LANE ON AN ICY TUESDAY MORNING COMMUTE.THEN SHE LOSES ALL POWER AND ACCELERATION, EVERY LIGHT IN THE CAR COMES ON AND SHE REALIZES THERE IS A PROBLEM. SHE IS MID WAY UP A HILL AND HAS TO GET OVER. THERE IS AN ON RAMP TO HER RIGHT AND MORE TRAFFIC SO SHE HAD TO GO INTO THE LEFT BERM. BY THIS TIME SHE HAS PEAKED THE TOP OF THE HILL AND IS ON THE FLAT MESA. THERE IS VERY LITTLE ROOM TO MOVE OVER AND SHE IS OVER AS FAR AS POSSIBLE. STATE AND LOCAL TRAFFIC ENFORCEMENT COME TO HER AIDE AND ALLOW HER TO WAIT FOR ME AND A TOW TRUCK TO GET THE VEHICLE MOVED. NEARLY A DOZEN CARS ALMOST HIT THEM AFTER I ARRIVED ON THE SCENE BEFORE THE DETERMINED THAT IT WAS UNSAFE FOR US TO WAIT WITH THE VEHICLE. THEY TAGGED THE CAR AND WE HAD IT TOWED. IT TURNS OUT THAT THE IDLER PULLEY HAS SNAPPED AND IT IS A VERY COMMON PROBLEM WITH AVEOS. A VERY COMMON PROBLEM THAT PUT MY WIFE, TWO OFFICERS AND I IN HARMS WAY. LET ALONE THAT RECALLING THE SMALL PART WOULD HAVE SAVED EVERYONE A $1900-2500 REPAIR JOB. I UNDERSTAND THAT MANY CONSIDER THIS STYLE CAR DISPOSABLE BUT I SAY IT AS AN AFFORDABLE ENERGY EFFICIENT COMMUTER VEHICLE. HOWEVER THESE FEATURES ARE NOT WORTH HUMAN LIFE... *TR
Jan 07, 2014
I WAS DRIVING DOWN THE HIGHWAY AT 55 MPH AND THE CAR STARTED TO LOSE ACCELERATION. I PRESSED ON THE GAS AND NOTHING HAPPENED. I STARTED SLOWING VERY QUICKLY AND I PULLED OFF TO THE SIDE WHERE EVENTUALLY THE CAR COMPLETELY SHUT DOWN ALL ON ITS OWN AND THE BATTERY LIGHT CAME ON THE DASH. I TURNED THE IGNITION TO OFF AND RESTARTED THE CAR. I WAS ABLE TO KEEP GOING WITHOUT ANOTHER INCIDENT. THE NEXT DAY ON MY WAY HOME FROM WORK THE SAME THING HAPPENED AGAIN. MY CHECK ENGINE LIGHT WAS ON AT THE TIME FOR WHICH I JUST HAD MY FUEL CAP REPLACED BECAUSE IT WAS NOT LOCKING AT ALL. AFTER A FEW DAYS MY CHECK ENGINE LIGHT HAS GONE OFF. I AM SERIOUSLY CONCERNED ABOUT THIS AS THIS CAR IS MY MAIN MEANS OF TRANSPORTATION BACK AND FORTH TO WORK WHICH IS AN HOUR DRIVE FOR ME. I JUST RECENTLY PURCHASED THIS CAR (WITHIN THE LAST 3 WEEKS) FROM THE FORD DEALERSHIP IN TILLAMOOK OR AND OF COURSE THEY DID NOT REPORT ANY OF THESE ISSUES. *TR
Jun 12, 2013
ELECTRICAL SYSTEM,INTERIOR LIGHTING
3 complaints
DASH LIGHTS DO NOT WORK ON CHEVY AVEO LS AND WE CANNOT SEE OUR INSTRUMENTS BECAUSE THERE ARE NO LIGHTS AT NIGHT AND HOW FAST WE ARE GOING. WE FEEL VERY UNSAFE FOR NIGHT DRIVING. *TR
Oct 18, 2010
TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT THE KEY CONTINUOUSLY WOULD BECOME STUCK IN THE IGNITION AND CAUSE THE GEAR SHIFT TO BECOME LOCKED IN GEAR WHETHER DRIVING OR IF THE VEHICLE WAS TURNED OFF. IN ADDITION, THE INTERIOR LIGHTS FAILED AND ONLY THE RADIO AND CLOCK LIGHTS WOULD ILLUMINATE. THE VEHICLE WAS NEITHER INSPECTED NOR REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 80,000.
Sep 14, 2010
INTERIOR LIGHTS, HEADLIGHT WARNING ON LIGHT, AND CABIN ILLUMINATION LIGHT FAILED. *TR
Nov 05, 2009
STRUCTURE
3 complaints
BODY RUST,ALL AROUND THE DOORS. AND TRUNK LID..AND HAVE HAD MY TIMEING BELT PULLY FIXED AFTER 42,000. NO DAMAGE UNDER WARRANTY.NOW MY CLOCK LIGHT IS OUT...WHAT DO I DO..TRADE IT OFF... *TR
Sep 12, 2010
MY 2005 AVEO DIED ON THE 80 FREEWAY AT 65 MPH. THERE WERE NO WARNING SIGNS. DIAGNOSIS:IDLER PULLEY SNAPPED IN TWO CAUSING SEVERE ENGINE DAMAGE REQUIRING NEW ENGINE TO FIX. VERY DANGEROUS TO HAVE YOUR CAR JUST DIE ON A FAST MOVING 4 LANE FREEWAY. 60,455 MILES ON VEHICLE AT THE TIME. *TR
Oct 14, 2009
DT*: THE CONTACT STATED DURING A RAIN STORM TODAY WATER ENTERED THE VEHICLE ON THE DRIVER SIDE AROUND THE DASHBOARD AND POOLED UNDERNEATH THE DRIVER SEAT. AN APPOINTMENT HAS BEEN MADE WITH THE DEALER FOR INSPECTION LATER TODAY.
May 03, 2006
ENGINE AND ENGINE COOLING,EQUIPMENT
3 complaints
DRIVING HOME FROM WORK ON 8/26/2010, THE THERMOSTAT HOUSING JUST SPLIT IN HAVE ON MY 2005 CHEVY AVEO LS. THE ANTIFREEZE SPILLED OUT AND I NEEDED TO HAVE THE CAR TOWED. THE THERMOSTAT HOUSING IS MADE OF CHEAP PVC PIPE LIKE MATERIAL AND IS IN TWO PIECES THAT APPEAR TO BE GLUED TOGETHER. A VERY LOW GRADE RISKY DESIGN IN MY OPINION. THE REPLACEMENT PART IS ONLY AVAILABLE FROM A GM DEALER AT A COST OF $98 PLUS TAX. THE REPLACEMENT PART IS MADE OF STURDY ALUMINUM. IT APPEARS TO BE A BETTER DESIGN AND STRUCTURALLY SOUND. MY COMPLAINT IS, GM OBVIOUSLY KNEW THIS PART WAS SUBSTANDARD. EVIDENCE OF THAT IS THE REENGINEERED REPLACEMENT PART. GM SHOULD HAVE RECALLED THE CHEVY AVEO'S AND REPLACED THE CHEAP/DEFECTIVE THERMOSTAT HOUSING INSTEAD OF NOT INFORMING OWNERS OF THE DEFECT, AND ALLOWING THE PART TO FAIL ON THE OPEN ROAD. FURTHER, THE COST OF $98 PLUS TAX FOR THE UPGRADED THERMOSTAT HOUSING SHOULD NOT PASSED ON TO THE OWNER/CUSTOMER. GM SHOULD REFUND THAT COST AND/OR RECALL THE VEHICLES FOR FREE REPLACEMENT. THIS IS A SAFETY CONCERN, ESPECIALLY WHEN YOU BREAK DOWN ON A INTERSTATE HIGHWAY, IN A SMALL COMPACT CHEVY AVEO, WITH SMALL CHILDREN IN THE CAR. I HAVE READ HUNDREDS OF BLOGS ONLINE OF CHEVY AVEO OWNERS THIS SAME PART HAS FAILED ON (AFTER MINE FAILED). IT'S APPALLING THAT THERE HAS NOT BEEN A RECALL ON THIS ISSUE, AND THAT THE NHTSA HAS NOT FORCED GM TO RECALL THE VEHICLES WITH THIS CHEAP/FAULTY THERMOSTAT HOUSING. IT'S NOT ONLY A SAFETY ISSUE, BUT NO ENGINE LIGHT COMES ON WHEN THIS HAPPENS, SO A PERSON CAN CONTINUE DRIVING AND CAUSE FURTHER SERIOUS DAMAGE TO THE CAR IF THE ENGINE BLOCK SEIZES UP, ETC. *TR
Aug 29, 2010
2005 CHEVY AVEO. THERMOSTAT IS ORIGINALLY, FROM FACTORY, PERMANENTLY ENCASED IN A PLASTIC TYPE HOUSING. THIS IS ALL ONE (1) PIECE. CHEVY HAS SUPERSEDED THIS ITEM WITH A METAL TYPE HOUSING WITHIN THEIR RANKS/COMPUTERS, BECAUSE IT WAS A KNOWN ISSUE. THIS ITEM (PLASTIC THERMOSTAT HOUSING) KNOWINGLY SPLITS AS EARLY AS 30,000 MILES. FOR US IT WAS ABOUT 46,000 MILES. THIS WAS NEVER A RECALL ITEM NOR WAS ANY INFORMATION EVER SENT OUT WARNING ABOUT IT. FAILURE OF THIS PART LEADS TO THE KNOWN LEAKING AND EXPELLING OF HAZARDOUS ANTI-FREEZE/COOLANT ON ROADS BUT ALSO LEADS TO THE UNREALIZED OVERHEATING OF ENGINE. THIS CAN LEAD TO UNNECESSARY ENGINE DAMAGE FROM SIMPLE OVERHEATING OF OIL TO THE EXTREME OF BLOWN HEAD GASKETS, BLOWN/BROKEN CYLINDER RINGS, WARPED ENGINE HEADS OR COMPLETE ENGINE SEIZURE. CHEVY RETAILS THE NEW METAL PART FROM $82.00 - $95.00. THIS FAILING PART WAS KNOWN EARLY ENOUGH THAT THE NEW PRODUCT HAD ALREADY BEEN MADE AND DISTRIBUTED TO DEALERSHIPS. WEB LOGS ARE FULL OF THIS PARTICULAR FAILURE, ON THIS VEHICLE. *TR
Sep 02, 2008
I HAVE A 2005 CHEVY AVEO AND RECENTLY WAS DRIVING TO WORK WHEN IT STARTED TO SMOKE AND MAKE FUNNY NOISES, AFTER BEING FIXED AT THE DEALERSHIP, I WAS TOLD THAT THE CLUTCH WAS RED HOT, CRACKED THE PLATE AND THE FLY WELL AND WAS A HAZARD TO DRIVE, I HAVE ONLY HAD THE CAR THREE YRS AND NEVER DID ANYTHING TO CAUSE THIS, I AM WONDERING IF THIS WAS A MANUFACTURE OR MECHANICAL ISSUE WITH THE CAR, I ENDED UP PAYING 854$ TO FIX THE CAR BUT FOR THE TIME THAT I WAS WITHOUT IT, I HAD TO TAKE A BUS TO WORK FOR THREE WEEKS AND RELY ON FRIENDS TO HELP ME OUT. IS THIS CAR SAFE? *TR
Jun 24, 2008
UNKNOWN OR OTHER
2 complaints
NOTHING HAPPENED, BUT I SAW THAT THE CHEVROLET AVEO'S STATUS WAS DEEMED, "RECALL INCOMPLETE," AND I WANTED TO KNOW WHAT I SHOULD DO WITH THE CAR; IF THERE ARE ANY REPAIRS THAT NEED TO BE DONE OR IF REPAIRS CANNOT BE DONE. I DON'T HAVE ANY PHOTOS BECAUSE I DON'T UNDERSTAND IN DEPTH WHY THIS VEHICLE WAS RECALLED, BUT I WANTED TO KNOW IF THIS IS VERY CONCERNING OR NOT.
Aug 28, 2019
TIMING BELT IDLER PULLEY FAILURE PLASTIC BREAKS APART. DAMAGING INTERNAL PARTS CAUSING ENGINE TO STOP RUNNING. WITH LOSS OF POWER STEERING POWER BRAKES
Oct 24, 2014
ELECTRICAL SYSTEM,VISIBILITY
2 complaints
TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT THE FUSE BURNED AND CAUSED ALL OF THE WINDOWS TO MALFUNCTION. THE CONTACT REPLACED THE FUSE, BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 86,000.
Sep 08, 2014
2005 CHEVY AVEO HATCHBACK/ALL ELECTRICAL. ELECTRICAL WINDOWS WILL ROLL DOWN AND THEN COMPLETELY STOPPED WORKING. CAR HAS NEVER BEEN IN AN ACCIDENT AND HAS NEVER HAD ANY DAMAGE. BOUGHT CAR BRAND NEW. *TR
Jul 15, 2010
STEERING
2 complaints
SON GOING TO WORK AND STEERING LOCKED UP GOING INTO A TURN CAUSING THE CAR TO GO STRAIGHT INTO A POWER POLE. SON HAD TO BE EXTRACTED OUT OF CAR AND LIFE-BIRD INTO HOSPITAL WITH FACIAL LACERATION, BROKEN AN DISPLACED ELBOW AN SLIGHT CONCUSSION. ACCIDENT WAS IN THE MORNING AND THAT AFTERNOON WAS A RECALL NOTICE ON THE CAR. SON WAS LUCKY, VERY LUCKY JUST TO HAVE THESE INJURIES. CAR TOTALED. *JS
Jul 28, 2014
LANE CHANGE RESULTED IN STEERING FAILURE AND ROLL-OVER OF VEHICLE. THE RIGHT FRONT TIRE WAS FLAT AFTER THE ACCIDENT. WAS THE ACCIDENT CAUSED BY THE STEERING OR THE TIRE? DRIVER ESCAPED WITH BRUISING ONLY. SEAT BELT HELD. GENERAL MOTORS HAS BEEN NOTIFIED & IS INVESTIGATING. *TR
Aug 08, 2009
ENGINE AND ENGINE COOLING,POWER TRAIN
2 complaints
2005 AVEO (BOUGHT NEW) WITH TIMING BELT FAILURE DESTROYING ENGINE. HAD THIS HAPPENED ON THE INTERSTATE AT 70 MILES AN HOUR IT COULD HAVE BEEN FATAL. FROM MY RESEARCH GMC HAS KNOWN ABOUT THIS ISSUE SINCE AT LEAST 2006 AND YET HAVE NOT ASSISTED CONSUMERS TO CORRECT THIS NOR RECALLED THEIR CAR. I HAVE READ REPORTS ON ALMOST ALL YEARS OF AVEO HAVING THIS PROBLEM WELL BEFORE THE 60000 RECOMMENDED TIMING BELT REPLACEMENT. TWO DIFFERENT MECHANICS CONFIRMED TIMING BELT FAILURE. ALL I GET FROM GMC IS THE RUN AROUND. UPSET OVER MONEY BUT MORE CONCERNED ABOUT THESE CARS BEING ON THE HIGHWAYS AND CREATING SOME HORRIBLE ACCIDENT WHEN THE ENGINE SUDDENLY STOPS WORKING AND CONTROLLING THE CAR IS DIFFICULT OR IMPOSSIBLE. PLANNING TO GET RID OF MINE, CAN'T AFFORD THE THOUSANDS OF DOLLARS TO FIX NOR DO I TRUST THIS CAR. *TR
Apr 09, 2012
TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. WHILE DRIVING THE VEHICLES ENGINE WAS BECAME HOT. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY FOR INSPECTION. THE TECHNICIAN REPLACED THE MAIN COMPUTER. THE CURRENT AND FAILURE MILEAGES WERE 85000. UPDATED 01/05/10. *LJ THE CONSUMER STATED THE VEHICLE WAS MANUFACTURED WITH A PLASTIC TEMPERATURE HOUSING WHICH EVENTUALLY MELTED DUE TO EXTREME HEAT IN TEXAS, WHICH CAUSED THE VEHICLE TO GET HOT AND THE ENGINE TO BURN UP. THE ENGINE AND COMPUTER WERE REPLACED. AFTER 2 MONTHS OF DRIVING, THE TRANSMISSION FAILED. UPDATED 01/07/10.*JB
Dec 15, 2009
SERVICE BRAKES, ELECTRIC
2 complaints
05 CHEVY AVEO VEHICLE BRAKE PEDAL DOES NOT WORK WHEN GOING ANYWHERE AFTER IT HAS BEEN PARKED LONG ENOUGH TO COOL DOWN. I EVEN LET THE CAR WARM UP FOR 15 MIN AND STILL NO BRAKES FOR ABOUT 2-3 MILES BRAKE PEDAL EXTREMELY HARD TO PUSH DOWN. PROBLEM HAS WENT ON FOR ABOUT 6 MONTHS NOW NO LEAKS BRAKE PADS ARE GOOD ETC. MECHANICS SAID THEY HAVE NO IDEA WHY THE BRAKES FAIL TO WORK. I ALMOST RAN OVER A LITTLE KID YESTERDAY. *TR
Feb 06, 2011
YESTERDAY, I TOOK MY 2005 CHEVY AVEO LT (53,400 MI) INTO THE LAVERY DEALERSHIP IN ALLIANCE, OHIO, FOR REPLACEMENT OF AN EXTENDED WARRANTEED ABS SENSOR. WHEN THEY REMOVED THE FRONT WHEELS, THE BRAKE PADS LITERALLY FELL OFF. THE PADS HAD RUSTED OFF THE BACKS OF THE PADS! THE MECHANIC SAID THEY WOULD NOT HAVE HAD TO HAVE BEEN REPLACED (THE PADS WERE STILL A FULL 1/4" THICK) EXCEPT FOR THE FACT THEY RUSTED OFF THE BACKS!!!) THESE ARE GM PART #96475176, ACD#171-0877, GM DAEWOO, MADE IN KOREA (I STILL HAVE THE OLD PARTS). THEY ARE CHEAP QUALITY AND COULD HAVE COST ME MY LIFE HAD THEY NOT BEEN DISCOVERED! AS THE MECHANIC EXPLAINED TO ME, THE DANGER IS IF ONE OF THE SEPARATED PIECES OF THE BRAKES SLIPPED AND MOVED FORWARD, IT COULD IMMEDIATELY LOCK THE BRAKES! DEALER REPLACED THE FRONT BRAKES AT MY EXPENSE. THE ABS BRAKE WARNING LIGHT HAD NEVER COME ON. *TR
Sep 19, 2009
ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM
2 complaints
WAS DRIVING TO WORK AND WENT THROUGH A DRIVE THROUGH FOR COFFEE. NOTICED THAT WHILE IDLE, MY CAR STARTED TO OVER HEAT. CONTINUED ON TO WORK APPROX 1 MILE DOWN THE ROAD. WHEN I GOT THERE I OPENED THE HOOD AND FOUND THAT A HOSE WAS NO LONGER CONNECTED TO THE THERMOSTAT HOUSING. THEN I NOTICED THAT THE PLASTIC HOUSING ITSELF WAS CRACKED IN HALF AND HANGING OFF THE CAR. IT COST ME ABOUT $80 FOR A REPLACEMENT METAL PART WHICH I HAD INSTALLED BY A FRIEND. THIS HAPPENED DURING THE SUMMER 2010; CAR HAD APPROX 51,000 MILES. IT IS NOW DECEMBER 2010, AND CAR HAS APPROX 56,00 MILES. MY CHECK ENGINE LIGHT IS ON AND I BROUGHT THE CAR TO A CAR PART STORE TO HAVE THEM CHECK THE CODE. APPARENTLY NOW I HAVE TO REPLACE THE OXYGEN SENSOR, WHICH COSTS ABOUT $150.00 + LABOR. I BOUGHT THIS CAR USED IN 2007 AND STILL HAVE ABOUT 2 YEARS LEFT TO PAY ON IT. THE WARRANTY IS NO LONGER GOOD. *TR
Dec 16, 2010
CONSUMER LETTER CONCERNING ENGINE SERVICE LIGHT ILLUMINATED. *TS THE ENGINE LIGHT ILLUMINATED DUE TO A FUEL GAUGE ERROR THE FIRST TIME. WHEN THE ENGINE LIGHT ILLUMINATED AGAIN, THE DEALER EXPLAINED THAT THE WIRING HARNESS NEEDED TO BE RELOCATED AND NOT REPAIRED. *JB
May 16, 2006
FUEL/PROPULSION SYSTEM
1 complaint
THIS IS NOT MY VEHICLE. I AM REPORTING FRAUD BY GM. PLEASE REVIEW THE INFORMATION I AM SUPPLYING BECAUSE THE NEW GM FAILED TO DO SO.*DT *JS
Sep 13, 2020
AIR BAGS,STRUCTURE
1 complaint
MY DAUGHTER CAME TO A STOP IN TRAFFIC AT A RED LIGHT 50 FEET FROM THE CAR IN FRONT OF HER AND WAS HIT IN THE REAR TRAVELING AT ABOUT 40 MILES PER HOUR KNOCKING HER IN TO THE CAR IN FRONT OF HER THE AIR BAGS DID NOT DEPLOY AND GM'S INVESTIGATION SAYS SHE WASN'T HIT HARD ENOUGH. SHE WAS SENT TO THE HOSPITAL VIA EMS WITH BACK AND NECK INJURY'S THIS WHOLE ACCIDENT WAS CAUGHT ON THE CAR WASH VIDEO CAM .
Jun 19, 2017
SERVICE BRAKES
1 complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. WHILE REVERSING, A GRINDING NOISE WAS HEARD COMING FROM THE REAR BRAKES. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DISCOVERED THAT THE REAR BRAKES WERE RUSTED AND CORRODED. THE BRAKES WERE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000. MA 10/21/15 THE CONSUMER STATED THE REAR BRAKES LOCKED UP. THEY WERE NOT GETTING ANY LUBRICANT. UPDATED 01/15/16.*JB
Aug 31, 2015
EXTERIOR LIGHTING,INTERIOR LIGHTING
1 complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. WHILE DRIVING AT AN UNKNOWN SPEED, THE INTERIOR LIGHTING AND HEADLIGHTS SUDDENLY SHUT OFF. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING). THE APPROXIMATE FAILURE MILEAGE WAS 22,000.
Jun 25, 2015
STEERING,POWER TRAIN,VEHICLE SPEED CONTROL
1 complaint
CAR WENT TO 500 RPM THEN DROPPED TO 300 RPM THEN DOWN TO 100 RPM; I IMMEDIATELY PULLED OFF THE MAIN ROAD TO A SIDE STREET. LOST POWER STEERING AND WAS UNABLE TO RESTART CAR AGAIN. CAR TAKEN TO LOCAL MECHANIC AFTER RUNNING DIAGNOSTIC TESTS ON THE VEHICLE, DETERMINED THE CAR WAS SAVABLE AND THAT THE TIMING BELT BROKE CAUSING THREE SETS OF VALVES TO BEND. THE TIMING BELT KIT, HEAD GASKET, WATER PUMP AND VALVE KITS NEED TO BE CHANGED. THE ENGINE NEEDS TO BE RECONDITIONED; NEW ENGINE OIL NEEDS TO BE PUT INTO THE CAR ALONG WITH FLUSHING THE FLUIDS. SINCE THIS IS A MASSIVE REWORK OF THE VEHICLE, IT WILL BE OUT OF SERVICE ONE WEEK AND THE REPAIR COST IS $2,100.00. MILEAGE ON THE CAR IS UNDER 60,000, I AM ORIGINAL OWNER. GENERAL MOTORS - CHEVROLET DIVISION CONTACTED BECAUSE I DID NOT TAKE TO A GM DEALER FOR SERVICE (UNABLE TO AFFORD) AND BECAUSE THEY ADVISED ME THIS IS SO FAR OUT OF THE WARRANTY, THEY WOULD NOT OFFER ANY ASSISTANCE. HOWEVER, I DID LOOK UP A SERVICE BULLETIN AND IT DID SAY THE PARTS ARE UNDER WARRANTY. *TR
Dec 17, 2014
POWER TRAIN,ENGINE
1 complaint
WAS DRIVING ON I-94 FROM MILWAUKEE TO CHICAGO, ONCE IN KENOSHA AREA THE CAR CHOKED, HEARD A BIG NOISE AND DIED COMPLETELY WOULD NOT TURN ON AGAIN. PUSHED IT TO THE SHOULDER AND CALLED 911. THE DOT TOWED THE CAR TO SAFETY AND THEN IT WAS BROUGHT TO THE SHOP. THE MECHANIC DESCRIBED THE PROBLEM AS THE IDLER PULLEY AND THE TIMING BELT ARE BROKEN DOWN AND THIS CAUSE THE VALVES AND PISTON TO BE COMPLETELY DAMAGED. THE CAR WAS ALWAYS MAINTAINED ACCORDING TO GM RECOMMENDATION, TIMING BELT PERFORMED BY HALL CHEVROLET DEALER AT 67000 AND OIL CHANGE WAS REGULARLY DONE AT 3000MILES. ALSO THE CAR HAS A COMPLETE 92000 MILES REVIEW WITH HEISER CHEVROLET BACK IN MARCH WITH ALL THE MAINTENANCE RECOMMENDED BY GM (TRANSMISSION, COOLANT, BELTS, HOSES...ETC). THE CAR IS STILL IN GREAT SHAPE. THE TIMING BELT AND THE IDLER PART MUST BE DEFECTIVE. *TR
Sep 04, 2014
ENGINE AND ENGINE COOLING,EXTERIOR LIGHTING
1 complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT THE ENGINE OVERHEATED AND THE TEMPERATURE GAGE DISPLAY STATED THAT THE VEHICLE WAS OVERHEATING. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE DRL MODULE NEEDED TO BE REPLACED. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN ID NUMBER: 14V261000 (EXTERIOR LIGHTING), HOWEVER THE PART NEEDED TO PERFORM THE RECALL REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 32,000.
Aug 21, 2014
VEHICLE SPEED CONTROL,SERVICE BRAKES
1 complaint
FOR THE LAST TWO YEARS AT RANDOM TIMES WHEN I START MY CAR, THE BRAKES WILL NOT WORK. THEY CAN NOT EVEN BE PRESSED DOWN. WHENEVER THIS HAPPENS, A CORRESPONDING WEIRD REVVING THAT CAUSES THE CAR TO LUNGE FORWARD IN SUCH A WAY THAT IT DOESN'T USUALLY ALSO HAPPENS. I PARALLEL PARK ON A STREET DAILY, AND ONE MORNING WHEN THIS HAPPENED ENDED UP HITTING THE CAR IN FRONT OF ME. USUALLY THE PROBLEM STOPS HAPPENING AFTER DRIVING FOR ABOUT 1/2 A MILE, BUT IT IS PRETTY SCARY TRYING TO DRIVE WITHOUT BRAKES TO GET TO THAT 1/2 MILE MARK. ESPECIALLY SINCE WHENEVER THE BRAKES WON'T WORK THE CAR ALSO SEEMS TO ACCELERATE ON ITS OWN. I HAVE TRIED TO GET THIS FIXED MULTIPLE TIMES BUT IT ALWAYS STOPS HAPPENING BY THE TIME I GET TO THE MECHANIC AND I'VE LEFT MY CAR OVERNIGHT AT A MECHANIC TWICE AND THEY HAVEN'T BEEN ABLE TO RECREATE THE ISSUE. I CAN'T PART WITH MY CAR FOR AN ENTIRE WEEK SO THAT THIS PROBLEM CAN BE DIAGNOSED. *TR
Jul 25, 2014
ELECTRICAL SYSTEM,EXTERIOR LIGHTING,STRUCTURE
1 complaint
1. MULTIPLE TIMES, MY DRIVER SIDE DOOR LOCK HAS COMPLETELY FALLEN INTO THE DOOR. I HAVE PROBABLY HAD THIS ISSUE "REPAIRED" FIVE TO SIX TIMES, BY BOTH THE CHEVROLET DEALER WHERE I BOUGHT THE CAR, AS WELL AS MY OWN MECHANIC. 2. THINGS THAT WERE WRONG WHEN WE FIRST BROUGHT THE CAR TO THE DEALER FOR REPAIRS IN EARLY APRIL 2014. THIS IS THE LIST WE GAVE THEM, MODIFIED FOR SPACE: *CLOCK A COUPLE YEARS AGO, THE CLOCK IN MY CAR STOPPED WORKING. OFTEN, THE CLOCK WOULD READ 1:00 WHEN I TURNED THE CAR ON, NO MATTER WHAT TIME IT WAS. SOMETIMES, IT WOULD RANDOMLY DISPLAY ANOTHER TIME. EVENTUALLY, IT JUST STOPPED TURNING ON ALTOGETHER. *CD PLAYER THREE TIMES, THE RADIO AND/OR CD PLAYER HAVE TURNED ON AND OFF BY THEMSELVES. THIS HAS NOT HAPPENED RECENTLY. THE CD PLAYER SOMETIMES WORKS JUST FINE. OTHER TIMES, IT DOES NOT. WHEN IT DOES NOT WORK, IT DOES ONE OF TWO THINGS. IT WILL EITHER SPIN AND SPIN AND SPIN AND THEN SPIT THE CD OUT, OR, MORE OFTEN, IT WILL READ ?ERROR 7.? I DO NOT KNOW IF THE LATTER IS CONNECTED TO THE OTHER ISSUES DESCRIBED HERE, BUT THE FORMER (THE TURNING ON AND OFF) PROBABLY IS. DAYTIME RUNNING LIGHTS THE DAYTIME RUNNING LIGHTS NO LONGER WORK. MY REGULAR MECHANIC TRIED REPLACING THE BULBS, BUT NEW BULBS DID NOT SOLVE THE PROBLEM. I MUST MANUALLY TURN THE LIGHTS ON. REVERSE LIGHTS SOMETIMES THE REVERSE LIGHTS COME ON WHEN I PUT THE CAR IN REVERSE. SOMETIMES, THEY DO NOT TURN ON WHEN I PUT THE CAR IN REVERSE. INTERIOR LIGHTS/GAUGES ABOUT 10 DAYS AGO, ALL THE INTERIOR LIGHTS AND GAUGE LIGHTS STOPPED TURNING ON, EVEN WHEN I MANUALLY TURN THE HEADLIGHTS ON. THE CAR INTERIOR IS COMPLETELY DARK. FOG LIGHTS I BELIEVE THESE MIGHT NOT BE WORKING EITHER. INTERIOR DOME LIGHT THE INTERIOR DOME LIGHT BURNED OUT. MY REGULAR MECHANIC REPLACED THE BULB, AND THAT FIXED THE PROBLEM. RIGHT TAIL LIGHT THE RIGHT TAIL LIGHT IS OUT. *TR
May 30, 2014
STRUCTURE,LATCHES/LOCKS/LINKAGES
1 complaint
THE ENTIRE LOCK OF THE DRIVER SIDE DOOR FELL INSIDE THE DOOR WHEN I TRIED TO UNLOCK MY DOOR. FIRST I TRIED TO FIX THE PROBLEM MYSELF, BUT SIMPLY COULD NOT REPAIR THE PROBLEM. HOWEVER, I RESEARCHED THE ISSUE ONLINE AND SAW THAT MANY, MANY OTHERS HAVE ENCOUNTERED THE SAME PROBLEM BEFORE WITH THIS MODEL. NATURALLY, BECAUSE I WOULD LIKE TO BE ABLE TO LOCK MY CAR DOOR, I TOOK IT IN AND HAD IT FIXED FOR $160. THE CUSTOMER SERVICE REP JUST SMIRKED WHEN I TOLD HIM WHAT HAPPENED AND SAID THAT WE MUST'VE PUSHED THE KEY IN TOO HARD "OR SOMETHING LIKE THAT". I WAS NOT HAPPY ABOUT THE COST, BUT I PAID. HOWEVER, JUST TWO WEEKS LATER, THE SAME PROBLEM OCCURRED WITH THE PASSENGER SIDE DOOR, WHICH I RARELY UNLOCK WITH THE KEY. APPARENTLY THE DEALER DOES NOT KNOW WHAT CAUSES THE PROBLEM. FORTUNATELY I WAS ABLE TO FIX IT MYSELF THIS TIME BUT HAD TO TAKE THE DOOR APART, BUT IT WAS TIME CONSUMING. IT IS VEXING TO ME THAT CHEVROLET MUST REALIZE THERE IS A PROBLEM, BUT DOES NOT SEEM TO WANT TO FIX IT. *TR
May 24, 2014
SUSPENSION,EXTERIOR LIGHTING,STRUCTURE
1 complaint
2005 AVEO LT ~ DAY OR NIGHT THE SAFETY HEADLIGHTS (HEADLIGHTS / OTHER) WILL JUST SHUT OFF FOR NO REASON AFTER BEING ON FOR LESS THAN AN HOUR. ~ IT'S NOT FUN DRIVING ON I-95 HERE IN EAST CENTRAL FLA. AND ALL OF THE SUDDEN YOUR HEADLIGHTS DISAPPEAR ! ! ! ~ ONE MONTH AFTER WE BOUGHT THE CAR (USED) FROM ROSNER CHEVROLET (MELBOURNE, FLA.) THE FRONT END SUSPENSION STARTED SQUEAKING, ~ AND THE THERMOSTAT HOUSING CAME APART. *TR
Apr 23, 2014
SUSPENSION,ENGINE
1 complaint
I JUST BOUGHT THIS 2005 CHEVY AVEO 2 WKS AGO WHEN THE ALTERNATOR WENT OUT OF MY CAR AND I WAS HAVING SURGERY THE NEXT DAY THEN WOULD NEED A CAR FOR WORK 2 DAYS LATER, SO I HAD NO TIME TO PROPERLY LOOK FOR A CAR. I JUST CAME OFF THE EXIT OF A 4 LANE HIGHWAY 1.5HRS AWAY FROM HOME. AS I WAS SLOWING TO STOP THERE WAS A BUNCH OF WHITE SMOKE (TURNED OUT TO BE STEAM) BILLOWING OUT FROM UNDER THE HOOD AND THE CAR ENGINE STOPPED RUNNING. A MAN HELPED PUSH THE CAR OFF THE ROAD AND THEY LOOKED UNDER THE HOOD AND DISCOVERED THE THERMOSTAT HOUSING SPLIT APART. IT'S PLASTIC! THE HOUSING WAS CLEARLY DEFECTIVE SINCE IT WAS SHEARED IN HALF AS IF CUT WITH LARGE KNIFE. HOW STUPID! HE GAVE MY HUSBAND A RIDE TO THE NEAREST NAPA AUTO PARTS WHERE THE ORDERED FROM ANOTHER DEALER. WE HAD TO WAIT 1.5HR AND THE OWNER HELPED REPLACE IT. THE NEW ONE WAS METAL! PUT ANTIFREEZE IN AND TRIED TO START THE CAR SEVERAL TIMES AND IT WON'T START. HAD TO HAVE THE CAR TOWED. I GOT ON THE COMPUTER FOR HELP DIAGNOSING THE PROBLEM AND DISCOVER A MILLION COMPLAINTS ON EDMUNDS.COM, AUTOMOTIVE FORUMS, ETC. THAT GM HAS KNOWN ABOUT THIS AND OTHER PROBLEMS WITH THIS CAR FOR YEARS SUCH AS PLASTIC PULLY, TIMING BELT BREAKS THAT COMPLETELY KILLS THE ENGINE. THAT'S WHERE I FOUND THIS SITE.THIS CAR IS A LEMON AND SHOULD BE RECALLED!!! HECK ON THIS SITE THERE ARE COMPLAINTS FROM 2011 AND STILL NO RECALLS! FROM WHAT I LEARNED READING ALL THE COMPLAINTS JUST ABOUT EVERYTHING IN THIS CAR IS JUNK. I AM NOT GOING TO PUT ANOTHER PENNY INTO THIS CAR. IT'S AT THE MILEAGE RANGE TO REPLACE THE TIMING BELT, THE PLASTIC PULLY, AND THE WATER PUMP, NOT TO MENTION THE ELECTRICAL STUFF. IT WOULD'VE BEEN CHEAPER TO RENT A CAR FOR THE 2WKS. STRUTS BUSTED. I'M GONNA TAKE THE LOSS AND NEVER BUY CHEVY AGAIN! PLEASE HELP US OWNERS GET CHEVY TO MAKE THIS RIGHT. THEY AND YOU HAVE KNOWN THE MANY PROBLEMS A LONG TIME! PLEASE DO THE RIGHT THING! *TR
Mar 28, 2014
POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE
1 complaint
HI I BOUGH A 2005 CHEVY AVEO WITH 9,000.00 MILE I HAD NO PROBLEM. UNTIL ONE DAY THE CAR COMPLETELY STOP AND WONT TURN ON. IT HAD ALMOST 23,000.00 WHEN IT HAPPEN. LUCKILY FOR ME IT STOP IN FRONT OF A MECHANIC SHOP. THE SHOP CHECK THE CAR AND SAID THE ENGINE IS BAD. I BOUGH A USED LOW MILEAGE ENGINE REPLACE IT AND IT TURN ON AND DRIVE EXCEPT FOR THE SHIFTING. IT DIDN'T SHIFT TO FOURTH GEAR AND ALSO TURN OFF WHILE DRIVING IT. THEN I WAS TOLD THE TRANSMISSION IS BAD. I CHANGE THE TRANSMISSION WITH LOW MILEAGE AND STILL I HAVE THE SAME PROBLEM I HAD WARRANTY CHANGE IT AGAIN AND STILL IT DOESN'T SHIFT FOURTH GEAR AND IT STILL TURNS OFF. I CHANGE THE COMPUTER, I DID A TUNE UP, ENGINE OIL CHANGE, I'VE CHANGE THE COILS AND SOME SEAL IN TOP OF THE ENGINE, AND I STILL HAVE THE SAME PROBLEM. THE CAR BEEN SITTING SINCE THEN I WANTED TO WAIT TO HAVE MONEY TO FIX IT, THINKING THAT MAYBE THE SHOP WAS LYING TO ME BY ASKING ME TO REPLACE ALL THIS THINGS. I SAVE I FEW DOLLARS AND WANTED TO GET IT FIX I HAD ANOTHER SHOP LOOKED AT IT AND IT SEEMS THAT IS THE SAME DIAGNOSTIC WAS DETECTED. I FRIEND TOLD ME TO GOOGLE IT AND I FOUND OUT THAT AM NOT THE ONLY ONE WITH THAT PROBLEM. I JUST WISH I GOOGLE IT BEFORE I SPEND ALL THE MONEY ON IT. LESSON LEARN I HOPE THEY DO A RECALL BECAUSE I TOO WAS AFRAID TO DRIVE AND GET IN TO AN ACCIDENT BECAUSE IT TURN OFF ON ME . *TR
Jan 16, 2014
EXTERIOR LIGHTING,ELECTRICAL SYSTEM
1 complaint
LETTER FROM SENATOR CORKER ON BEHALF OF CONSTITUENT RE ISSUES WITH CHEVROLET AVEO. *SMD THE CONSUMER STATED THE INSTRUMENT PANEL LIGHTS WENT OUT ON THE DASHBOARD. A MECHANIC INFORMED THE CONSUMER, A PART UNDER THE HOOD, IN A FUSE BOX, KNOWN AS A SPLITTER, HAD BURNED OUT. *JB THE CONSUMER RECEIVED A RECALL NOTICE IN JULY 2014 AND THE PARTS ARE STILL NOT AVAILABLE. RECALL #14V261000 UPDATED 02/23/15.*JB
Jul 01, 2013
POWER TRAIN,EXTERIOR LIGHTING
1 complaint
THE SHIFT GEAR DOES NOT WORK MY BACK LIGHTS ARE ALL OUT I DID NOT KNOW THIS MY CHECK ENGINE LIGHT STAY ON I HAVE HAD NEW SENSORS PUT IN ONE WEEK AND THE NEXT WEEK CHECK ENGINE LIGHT COMES BACK ON WHAT IS WRONG WITH THIS CAR WHY WONT THEY RECALL IT I HAVE TO DRIVE THIS CAR CLOCK WONT KEEP RIGHT TIME GEAR SHIFT LIGHT GOES ON AN DOFF AND MY LOW BEAM AND HAVE HAD THIS CAR RIGHT OUT OF THE SHOW ROOM ONLY 13 MILES ON IT WHEN I GOT IT AND KNOW IT IS ALL MESS UP I DON'T KNOW WHAT TO DO ABOUT IT! *TR
Feb 23, 2013
SEAT BELTS,VEHICLE SPEED CONTROL
1 complaint
TL* THE CONTACT OWNS A 2008 CHEVROLET AVEO. THE CONTACT STATED THAT THE ACCELERATOR PEDAL FAILED AND WOULD DEPRESS TO THE FLOOR WHENEVER THE VEHICLE WAS DRIVEN DOWNHILL. THE CONTACT WAS ABLE TO SLOW THE VEHICLE DOWN BY APPLYING THE BRAKES. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THE FAILURE WAS UNKNOWN. THE CONTACT ALSO STATED THAT THE SEAT BELT MATERIAL BEGAN TO GET FUZZY AND WOULD GET CAUGHT IN THE RETRACTOR. THE DEALER STATED THAT THE SEAT BELT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 20,000.
Jul 11, 2012
ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM,AIR BAGS
1 complaint
COMING HOME FROM WORK, DASH LIGHTS GOT BRIGHTER, AIRBAG LIGHT STAYED ON, CAR TRIED TO STALL AROUND A CORNER WHEN BRAKES WERE PRESSED. TOOK IN FOR SERVICE, HAD ALTERNATOR AND BATTERY REPLACED, ALSO SERPENTINE BELT. THIS WAS 4 MONTHS AGO. PROBLEM WAS NOT FIXED, JUST MADE IT LESS SEVERE. SINCE THAT TIME, WHEN YOU HIT THE BRAKES THE HEADLIGHTS DIM. THE DASH CLOCK COMES ON AND OFF RANDOMLY, THE AIRBAG LIGHT IS ON ALL THE TIME. WHEN IT IS COLD (THE CAR, NOT THE WEATHER), THE TRANSMISSION HAS A HARD TIME SHIFTING. AS OF THIS MORNING IT WILL NOT START. AM GOING TO HAVE IT LOOKED AT TOMORROW MORNING, BUT DO NOT HAVE HIGH HOPES. BOUGHT CAR IN 2006 WITH 8,000 MILES ON IT, HAVE HAD SHIFT LOCK ASSEMBLY REPLACED, WHEEL BEARINGS, BATTERY, ALTERNATOR, SERPENTINE BELT. PROBABLY OTHER THINGS I CANNOT THINK OF RIGHT NOW. THE ELECTRICAL PROBLEM WORRIES ME THOUGH. *TR
Jun 12, 2012
SEATS
1 complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING INSPECTED BY A PRIVATE MECHANIC, THE WIRING HARNESS UNDER THE DRIVER'S SIDE FRONT SEAT CAUGHT FIRE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE DEALER CONFIRMED THAT THE WIRING HARNESS FAILED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED AND THE VIN WAS UNKNOWN. THE FAILURE AND THE CURRENT MILEAGE WAS 123,000.
Feb 16, 2012
POWER TRAIN,VISIBILITY
1 complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT THE VEHICLE WOULD HESITATE WHEN CHANGING GEARS AND IN ADDITION, THE HEATER WAS INOPERABLE. THE CONTACT WOULD ALSO SMELL SMOKE COMING FROM THE VENTS SPORADICALLY. THE DEALER AND A LOCAL MECHANIC WERE UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 93,000 AND THE CURRENT MILEAGE WAS 105,000. THE VIN WAS UNAVAILABLE.
Jan 10, 2012
ENGINE AND ENGINE COOLING,LATCHES/LOCKS/LINKAGES
1 complaint
2005 CHEVROLET AVEO. CONSUMER WRITES IN REGARDS TO TIMING BELT FAILURE *TGW THE CONSUMER STATED WHILE DRIVING 70 MPH, THE VEHICLE SUDDENLY STOPPED RUNNING, IT FELT AS THOUGH THE TRANSMISSION HAD FALLEN OUT. WHILE TRYING TO GET TO THE EMERGENCY LANE, THE VEHICLE WOULD NOT ACCELERATE. UPON INSPECTION, IT WAS DETERMINED THE TIMING BELT IDLE PULLEY HAD BROKEN, ALONG WITH THE SERPENTINE BELT, THERMOSTAT, WATER PUMP, AS WELL AS ALL OF THE 16 VALVES WERE BENT. THE TOTAL COST IN PARTS AND LABOR WAS $ 2,914.54. THE CONSUMER ALSO STATED THE DOOR LOCK CYLINDER FELL INTO THE DOOR PANEL, THE VACUUM SUPPLY LINE TO THE SENSOR WAS CRACKED, WHICH CAUSED A VACUUM LEAK.
Nov 08, 2011
FUEL SYSTEM, GASOLINE,POWER TRAIN,ELECTRICAL SYSTEM,EXTERIOR LIGHTING
1 complaint
I HAVE A 2005 CHEVROLET AVEO THAT HAS GIVEN ME NUMEROUS PROBLEMS. A LITTLE OVER A YEAR AGO I NOTICED I COULD NOT SHIFT MY CAR OUT OF PARK I HAVE TO USE A SCREWDRIVER TO SHIFT MY GEAR OUT OF PARK. SOON AFTER I NOTICED MY BRAKE LIGHTS STOPPED WORKING. I BOUGHT A BOX OF FUSES BUT THIS ONLY FIXED THE PROBLEM FOR LESS THAN A WEEK. EVERY TIME I PUT A NEW FUSE IN THE BRAKE LIGHTS WENT BACK OUT IN A DAY OR TWO. ONE DAY WHILE I WAS ON THE FREEWAY MY CAR JUST SUDDENLY STOPPED WITHOUT ANY WARNING. I TOOK THE CAR TO THE DEALER IT WAS STILL UNDER THE POWER TRAIN WARRANTY. IT WAS A ELECTRICAL PROBLEM CAUSING ALL OF THESE PROBLEMS AND COST OVER $2,000 TO FIX. A YEAR LATER THE PROBLEMS STARTED AGAIN I CAN'T MOVE MY GEAR WITHOUT USING A SCREW DRIVER, MY BRAKE LIGHTS AND HEADLIGHTS ARE OUT. IF I SLAM THE HOOD OF MY CAR ONE HEADLIGHT WILL COME ON WHICH SHOWS THAT SOMETHING IS WRONG WITH THE WIRING. THE ENGINE LIGHT AND HOLD MODE LIGHT FLASHES CONSTANTLY. I FEEL THIS CAR IS DANGEROUS BECAUSE THERE ARE NO BRAKE LIGHTS WHICH CAN EASILY CAUSE AN ACCIDENT. I WAS PULLED OVER BY THE POLICE BECAUSE OF NO BRAKE LIGHTS A $125 TICKET. I AM IN A BIND BECAUSE I REALLY NEED MY CAR FOR WORK BUT I DO NOT HAVE $2,000 (NO LONGER UNDER WARRANTY) TO FIX THIS CAR ONLY TO HAVE THE SAME PROBLEM HAPPEN AGAIN MONTHS FROM NOW. ALSO, I HAVE NOTICED A STRONG GAS SMELL FROM THE CAR THAT HAS ME CONCERNED. I HAVE READ SO MANY INTERNET POST FROM OTHER PEOPLE COMPLAINING ABOUT THE SAME PROBLEMS. THIS CAR SERIOUSLY NEED TO BE RECALLED BECAUSE IT IS ENDANGERING PEOPLE LIVES. *KB
Oct 11, 2011
ELECTRICAL SYSTEM,LATCHES/LOCKS/LINKAGES
1 complaint
THE KEY CYLINDER ON MY DAUGHTER'S 2005 AVEO ON THE PASSENGER SIDE JUST FELL IN THE DOOR WITHOUT EVEN PUSHING IN THE KEY. NOW SHE CANNOT EVEN UNLOCK OR LOCK HER CAR FROM THE PASSENGER SIDE. I CALLED THE DEALERSHIP AND OUR EXTENDED WARRANTY THAT WE PAID SO MUCH FOR EXPIRED IN MAY OF 2010. I TOLD THEM THAT IT IS REALLY A DEFECT IN THE CAR BUT THEY WANT TO CHARGE ME $115 PER HOUR TO FIX IT. I SEE THAT THIS HAPPENS TO ALOT OF THE AVEO CARS. I THINK GM SHOULD PAY FOR THE FIX. *TR
Nov 30, 2010
INTERIOR LIGHTING,ELECTRICAL SYSTEM
1 complaint
I GOT INTO MY CAR AT NIGHT TO DRIVE HOME FROM A FRIEND'S HOUSE. NONE OF MY INTERNAL LIGHTS, WITH THE EXCEPTION OF THE CLOCK AND RADIO, WOULD COME ON. DRIVING AT NIGHT WITHOUT BEING ABLE TO SEE YOUR DASH INSTRUMENTS IS NOT EASY. I AM TOLD IT HAS TO DO WITH A SHORT IN THE POWER DISTRIBUTION BOX. *TR
Nov 21, 2009
POWER TRAIN,ELECTRICAL SYSTEM,EXTERIOR LIGHTING
1 complaint
ON SUNDAY EVENING I ATTEMPTED TO PUT MY 2005 CHEVY AVEO INTO DRIVE AFTER PUTTING MY KEY IN THE IGNITION AND STARTING THE VEHICLE BUT THE SHIFTER WAS STUCK IN PARK. THE AVEO HAS A FEATURE CALLED THE "SHIFT LOCK RELEASE" WHICH IS A HOLE ON THE SHIFTER CONSOLE YOU CAN PUT A SCREWDRIVER OR OTHER TOOL INTO TO RELEASE THE SHIFTER INTO DRIVE IN THESE SITUATIONS. I WAS ABLE TO PUT THE CAR IN DRIVE AND MAKE IT HOME SAFELY AFTER USING THE SHIFT LOCK RELEASE BUT WHEN I GOT HOME I REALIZED MY KEY WAS STUCK IN THE IGNITION. MY CAR SAT UNLOCKED OVERNIGHT BECAUSE I COULD NOT GET THE KEY OUT. ON MONDAY I CALLED MY LOCAL GM DEALERSHIP IN SALEM, OH AND THEY STATED THEY WOULD NOT BE ABLE TO TAKE A LOOK AT MY CAR UNTIL TUESDAY. I SPENT THE ENTIRE DAY RESEARCHING ONLINE AND FOUND MANY CUSTOMERS WHO HAVE EXPERIENCED THIS SAME ISSUE WITH THE AVEO. LATER ON IN THE EVENING I REALIZED MY BRAKE LIGHTS WEREN'T WORKING BUT THERE WAS NOT A BLOWN FUSE OR SWITCH. I TESTED BOTH OF THE BRAKE LIGHTS AND THEY WERE STILL GOOD. ON TUESDAY I TOOK MY CAR TO THE DEALERSHIP AND IT COST ME $80 FOR THE MECHANIC TO TELL ME THE SHIFTER IS BAD, WHICH I ALREADY KNEW. THEY ALSO STATED IT WOULD BE $300 TO REPAIR THE SHIFTER. I STRONGLY BELIEVE THE FAILURE OF THE BRAKE LIGHTS, THE SHIFTER AND THE IGNITION ARE TIED TOGETHER AND SHOULD BE REPLACED BY GM AT NO COST TO ME. MY VEHICLE IS SITTING UNATTENDED WITH THE KEY IN IT, WHICH RUNS THE RISK OF IT BEING STOLEN. NOT TO MENTION WHEN I AM DRIVING I HAVE NO BRAKE LIGHTS TO ALERT THE OTHER DRIVERS I AM SLOWING DOWN OR STOPPING WHICH COULD CAUSE AN ACCIDENT. EACH TIME I ATTEMPT TO PUT THE CAR IN DRIVE I HAVE TO INSERT SOMETHING INTO THE SHIFT LOCK RELEASE TO SHIFT THE CAR AND THIS HAS BEEN GOING ON SINCE SUNDAY. *TR
Nov 17, 2009
ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM,EXTERIOR LIGHTING,INTERIOR LIGHTING
1 complaint
CAR TYPE: 2005 CHEVY AVEO PROBLEMS I HAVE HAD WITH THIS CAR; 1. OXYGEN SENSOR NEEDED REPLACEMENT BY 41,XXX MILES 2. AT 82,XXX MI. WIRING PROBLEMS IN FUSE BOX WIRES CAME LOOSE (POSSIBLY A FIRE HAZARD) BURNT THE WIRING HARNESS. (CHAR MARKS ON THE WIRING HARNESS) CAUSED THE INTERIOR (INSTRUMENT CLUSTER PANEL) AND EXTERIOR LIGHTS (DAYTIME RUNNING LIGHTS)(YELLOW LOWBEAMS THAT CONTROL TURN SIGNAL) TO TURN OFF WHILE DRIVING THE VEHICLE DURING THE NIGHT TIME. FIX COST ME $125.00 PLUS TAX 8.25% THIS ISN'T THE FIRST TIME I'VE HEARD OF THIS HAPPENING IN FACT ITS ON MANY ONLINE FORUMS AS HAPPENING TO SEVERAL OTHER PEOPLE. 3. AT 92,XXX MILES. THERMOSTAT HOUSING CRACKED IN THE CENTER WHERE THE THERMOSTAT IS LOCATED AT (THERMOSTAT HOUSING IS PLASTIC) VERY CHEAPLY MADE. NO PARTS HOUSES CARRY THIS ITEM. ITS A GM PART. GOT STRANDED 44 MILES FROM HOME AND HAD TO GET A TOW TRUCK TO BRING CAR HOME. COST; $115.00 + TAX CORRECTIONS MADE TO VEHICLE; 1. PURCHASED A NEW OXYGEN SENSOR FOR ABOUT $120.00 2. TAKEN ELECTRICAL PROBLEM TO A SHOP AND HAD THE SHOP FIX IT FOR 125.00 +TAX 3. PROBLEM STILL PENDING. PARTS NOT AVAILABLE AT PART HOUSES I.E. AUTOZONE O'REILEYS A-LINE, ADVANCED AUTO, ETC....I BELIEVE PARTS HOUSES DO NOT WISH TO CARRY THESE PARTS. PART IS TOO CHEAPLY MADE FOR THEM TO CARRY I BELIEVE THE PART SHOULD HAVE BEEN MADE OUT OF METAL.(STEEL, ALUMINUM. ETC....) PROPERTY DAMAGE: DAMAGE TO WIRING HARNESS IN VEHICLE CHEVY AVEO FIRE: BURNT WIRING HARNESS IN VEHICLE, WIRES HAD TO BE SOLDERED FROM A SEPARATE LOCALITY IN ENGINE COMPARTMENT. *TR
Nov 01, 2009
POWER TRAIN,AIR BAGS
1 complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT THE TRANSMISSION LOCKED UP ON HIS VEHICLE. WHILE MAKING A RIGHT TURN, HE STATED THAT THE FRONT HALF OF HIS VEHICLE STOPPED, BUT THE REAR CONTINUED TO MOVE. THE SPEED WAS UNKNOWN. THE VEHICLE ROLLED OVER THREE TIMES DOWN AN EMBANKMENT AND WAS DESTROYED. THE VEHICLE WAS TAKEN TO THE DEALER ON THREE OCCASIONS AND THEY STATED THAT THE COMPUTER CONTROL TRANSMISSION SYSTEM FAILED. THE VEHICLE DOWNSHIFTS AND LOCKS INTO GEAR BY ITSELF. THE FAILURE BEGAN AFTER A RECALL WAS ISSUED BY THE MANUFACTURER. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT WAS THE ONLY OCCUPANT IN THE VEHICLE AND WAS NOT INJURED. A POLICE REPORT WAS FILED. GM DOES NOT ACCEPT RESPONSIBILITY FOR THE FAILURE. THE FAILURE MILEAGE WAS 98,000.
May 18, 2009
FUEL SYSTEM, GASOLINE,LATCHES/LOCKS/LINKAGES,VEHICLE SPEED CONTROL,EQUIPMENT,UNKNOWN OR OTHER,ELECTRONIC STABILITY CONTROL (ESC)
1 complaint
I PURCHASED A 2005 CHEVY AVEO AND I HAVE HAD NOTHING BUT PROBLEMS EVER SINCE. AFTER 1 YEAR THE CAR BROKE DOWN. THE IDLER STUCK AT FULL-THROTTLE AND BURNED MY TIMING BELT OFF. NOT ONLY THE ENGINE BUT THE CAR WAS RENDERED USELESS AFTER THAT. I HAD TO REPLACE THE ENGINE (MY POPS DID REALLY) AND NOW THE SECOND ENGINE HAS DONE THE VERY SAME THING AT ONLY 18,000 MILES. TWICE I WAS LUCKY ENOUGH TO BE IN A POSITION WHERE MY DAUGHTER WAS NOT WITH ME AT THE TIME AND I COULD PUSH MY CAR OFF OF THE ROAD MYSELF AND NOT GET KILLED. I CALLED GM AND THEY SAY THAT THEY CANNOT GUARANTEE THAT THEY WILL FIX THE PROBLEM FOR ME. THE FIRST TIME I TALKED TO THEM THEY WOULDN'T EVEN LISTEN TO ME. THEY TOLD ME THAT MY VIN NUMBER DID NOT MATCH THE RECALLS...THOUGH THESE CARS HAD THE VERY SAME PROBLEM. THE CAR SHOULD HAVE EITHER BEEN REPLACED OR I SHOULD HAVE GOTTEN MY MONEY BACK. I HAVE BEEN RENDERED HOMELESS AND JOBLESS TWICE NOW BECAUSE OF THIS CAR. I'VE LOST EVERYTHING. I CAN'T KEEP PAYING ON THIS CAR WITH THEIR FAULTY ENGINES. IF I REPLACE THE ENGINE IT WILL DO THE SAME THING. IT'S NOT VIN SPECIFIC...IT'S THE ENGINES PERIOD. I COULD HAVE GOTTEN KILLED TWICE! *TR
Apr 30, 2009
SUSPENSION,ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE,POWER TRAIN,ELECTRICAL SYSTEM,STRUCTURE
1 complaint
I TRADED IN A 2004 P.T.CRUISER TO GET A 2005 CHEVY AVEO AT THE TIME IT HAD 21000 MILES WHEN I GOT IT. MY WARRANTY WAS GOOD TILL 36000. I HAD LOTS OF ISSUES WITH A NOISE THAT STILL TO THIS DAY HAS NOT BEEN CORRECTED EVEN AFTER THREE ATTEMPTS UNDER MY CAR BY THE CHEVY SERVICE DEPT. I THEN HAD A COMPUTER RECALL OR SOMETHING THAT HAD TO BE REPLACED I ALSO HAD A GAS CAP THAT MALFUNCTIONED AND A CLOCK THAT HAD TO BE REPLACED. THOSE ARE THE NON LIFE THREATENING ISSUES. I HAD AN INCIDENT INSIDE OF THE ORIGINAL WARRANTY WHERE THE CAR THREW PARTS OUT OF THE ENGINE. IT WAS THE SERPENTINE BELT AND THE BRACKET THAT WAS METAL THAT IT WAS MOUNTED ON BROKE OUT OF THE ENGINE AS I WAS DRIVING IT. I AM CURRENTLY AT 55000 AND I HAVE THE POWER TRAIN ON IT. IN THE LAST MONTH I HAVE HAD THE CAR IN MY POSSESSION 1 WEEK THE REST IT'S BEEN IN THE SERVICE DEPT. A MONTH AGO THE PLASTIC AND YES THAT'S PLASTIC HOUSING FOR THE THERMOSTAT BLEW APART ON THE INTERSTATE CAUSING US TO HAVE TO DIAL 911 TO GET HELP BECAUSE WE WERE TRAPPED. TWO WEEKS AGO IT SPIT OUT THE TIMING BELT AND THE VALVES GOT BENT AND THE VALVE COVER WAS DAMAGED. WE DON'T KNOW WHAT PARTICLES ENDED UP IN THE ENGINE FOR NOW. I HAVE CONTACTED CHEVROLET ON ALL THESE ISSUES AND I ASKED THEM BEFORE MY WARRANTY WENT OUT AND RIGHT AFTER THE FIRST INCIDENT TO GIVE ME BACK THE MONEY FOR THE CAR. THEY CALLED ME TODAY AND SAID I DIDN'T HAVE A CASE BECAUSE THE WARRANTY WAS OUT I REMINDED THEM I HAD BEEN ASKING SINCE BEFORE AT THE FIRST INCIDENT WITH THE SERPENTINE AND BRACKET AND THEY SAID SORRY THE WARRANTY IS OUT. I REMINDED THEM I HAVE PICTURES OF THOSE PARTS AND CAN PROVE IT BUT THAT STILL WASN'T GOOD ENOUGH! I SPOKE TO HANNAH A DISTRICT SPECIALIST TODAY AND THAT IS WHO LIED TO HERSELF AND SAID THESE OCCURRENCES WERE AFTER THE WARRANTY. I HAVE PROOF CAN YOU PLEASE HELP BEFORE MY FAMILY DIES AND THEN WE HAVE DEPENDENTS WHO WILL OWN THE VERY COMPANY THE GOV'T IS TRYING TO BAIL OUT. I NEED YOU TO INTERVENE BEFORE I GO TO COURT OVER THIS. *TR
Mar 23, 2009
POWER TRAIN,EQUIPMENT
1 complaint
2005 AVEO 3RD TIME WITH THIS PROBLEM IT WILL NOT COME OUT OF PARK IT STICKS .2 TIMES THE DEALER TOLD ME IT WAS THE SHIFTER. 3RD TIME THEY TOLD ME IT WAS A BAD CONNECTION TO THE BRAKES. KNOW SENSE THEY STATED IT'S FIXED WHEN YOU PRESS THE BRAKE THE SHIFT CLICKS LOUD ALSO YOU DON'T HAVE TO PUSH THE SHIFTER DOWN IT JUST SLIDES UP AND DOWN.. NOT SAFE I NEED A GOOD CAR THAT I FEEL SAFE IN. *TR
Jul 06, 2008
FUEL SYSTEM, GASOLINE
1 complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET AVEO. WHILE DRIVING BETWEEN 55 AND 60 MPH, THE CONTACT STATED THAT THE PASSENGER COMPARTMENT SMELLED LIKE GASOLINE. THE ODOR WAS NOTICED ONLY WHEN DRIVING UPHILL. THE DEALER STATED THAT THE FUEL TANK "BURPS" AND THE GASOLINE SMELL INDICATES THAT THE CATALYTIC CONVERTER WAS WORKING PROPERLY. THE FAILURE MILEAGE WAS 34,000 AND CURRENT MILEAGE WAS 35,700.
Sep 06, 2007
AIR BAGS,SEAT BELTS
1 complaint
LTR FM REQUEST THE INVESTIGATION OF HIS 2005 CHEVROLET AVEO HIS SEATBELT FAILED AND AIRBAGS DID NOT DEPLOYED IN ACCIDENT**CC THE CONSUMER STATED HE WAS REAR ENDED ON JULY 30, 2007 WHICH RENDERED HIM UNCONSCIOUS AND HE WOKE UP IN AN AMBULANCE. THE CONSUMER WAS THROWN FROM THE DRIVERS SEAT, EVEN THOUGH HE HAD ON HIS SEAT BELT, THROUGH THE PASSENGER DOOR WINDOW, BREAKING IT IN THE PROCESS, THE DOOR DID NOT OPEN. THE CONSUMER WAS SEEN BEING EJECTED OUT THE WINDOW. THE CONSUMER THEN HIT ANOTHER VEHICLE FROM THE REAR. THE CONSUMER FURTHER STATED EVEN THOUGH THE CAR WAS SEVERELY DAMAGED THE AIR BAGS DID NOT DEPLOY. THE CONSUMER STATED HE WOULD LIKE AN INVESTIGATION AS TO WHY HIS SEAT BELTS FAILED AND AIR BAGS DID NOT DEPLOY DURING SUCH A SERIOUS ACCIDENT. *TR THE CONSUMER STATED AFTER SPEAKING WITH OTHER WITNESSES HE WAS APPARENTLY HIT IN FRONT AND SPUN AROUND AND THEN HIT ONCE AGAIN IN THE REAR. COMMONWEALTH OF VA POLICE REPORT ATTACHED. UPDATED 10/03/07 *TR
Sep 05, 2007
SUSPENSION,AIR BAGS
1 complaint
TRAVELING ON 695 DRIVING ON AN OVERPASS FROM WORK, 05 AVEO PULLED TO THE RIGHT. WHEN I ATTEMPTED TO CORRECT THE DIRECTION OF THE CAR BY TURNING SLIGHTLY LEFT, THE CAR COULD NOT BE CORRECTED WITH STEERING OR BRAKE, IT WENT LEFT ACROSS THE OTHER LANE AND HIT A JERSEY WALL. CAR ROLLED OVER. SPEED WAS ABOUT 50-55. I WAS LUCKY I HAD MY SEAT BELT ON AND WAS NOT HIT BY ANOTHER AUTO OR TRUCK. WHETHER WAS CLEAR BUT WINDY. TIME WAS 1:30PM. *TR
Sep 02, 2007
SERVICE BRAKES, HYDRAULIC,AIR BAGS
1 complaint
I WAS TRAVELING APPROXIMATELY 35 TO 40 MPH ON A STRAIGHT ROAD. THE VEHICLE IN FRONT OF ME STOPPED ABOUT 75 FEET AHEAD OF ME. I PRESSED ON THE BRAKE PEDAL TO STOP BUT THERE WAS NO PRESSURE AND IT WENT TO THE FLOOR. DUE TO HAVING NO BRAKES, I HIT THE BACK OF THE OTHER CAR. THE AIRBAG FAILED TO DEPLOY AND I HIT MY HEAD ON THE STEERING WHEEL. WHEN I REVERSED THE CAR AND PRESSED ON THE BRAKES AGAIN THEY WORKED. THE FRONT END OF THE CAR WAS SMASHED IN DAMAGING THE HEADLIGHTS, RADIATOR, HOOD, BUMPER, AND UNKNOWN OTHER PARTS AT THIS TIME. *TR
Sep 02, 2007
LATCHES/LOCKS/LINKAGES,UNKNOWN OR OTHER
1 complaint
I ARRIVED AT THE GAS STATION TO FILL UP AND WHEN I ATTEMPTED TO OPEN THE GAS CAP SHIELD, THE MECHANISM JAMMED AND I HAD TO PRY IT OPEN. THEN A FEW MOMENTS LATER, WHEN I ATTEMPTED TO LOCK THE DOOR FROM THE OUTSIDE, THE ENTIRE LOCKING MECHANISM ON THE DRIVER'S SIDE FELL INSIDE THE INTERIOR OF THE CAR DOOR. I HAVE CONTACTED THE DEALER AND WAS TOLD TO BRING IT IN. HOWEVER, UNTIL I DO THERE IS NO WAY TO LOCK THE DOOR! *NM
Feb 04, 2007
SEAT BELTS
1 complaint
DT*: THE CONTACT STATED THE REAR SEAT BELTS COULD NOT BUCKLE INTO THE CORRESPONDING LATCHES, WHICH REQUIRED THE BELTS TO BE CROSSED OVER TO THE OTHER SEAT BELT. THE SERVICE DEALER AND MANUFACTURER WERE NOTIFIED. THE MANUFACTURER INFORMED THE CONTACT THAT WAS THE DESIGN OF THE SEAT BELTS AND NOTHING WAS WRONG. UPDATED 12/18/2006 -*NM
Nov 06, 2006
STEERING,SUSPENSION
1 complaint
I HAVE HAD MANY PROBLEMS WITH THE STEERING AND SUSPENSION IN THIS VEHICLE. I HAD TO REPLACE THE TIRES AT LESS THEN 16,000. THE MAIN PROBLEM IS THAT WHENEVER I GO OVER ANY BUMPS THE CAR SQUEAKS AND MAKES A GRINDING SOUND. CHEVY SAID THAT THEY HAD TIGHTENED SOMETHING IN THE FRONT END TO TIGHT AT THE FACTORY AND THAT THEY HAD 3 OR 4 AVEOS COME BACK WITH THIS PROBLEM. THEY LOOSENED THEY TWO PIECES BUT I STILL HEAR THE SQUEAKS AND THEY TELL ME THAT THERE IS SOMETHING IN THE BACK END THAT IS GRINDING BUT IT IS A MANUFACTURING DEFECT AND THAT THEY CANNOT DO ANY THING. AND THEY HOPE IT DOESN'T DO ANYTHING. IF IT DOES AS LONG AS IT IS UNDER WARRANTY THEY WILL FIX IT. BUT I WOULD HATE FOR SOMETHING TO BREAK AND ME BE GOING 70 AND IT BREAK. *NM
Nov 11, 2005
STEERING,SERVICE BRAKES, HYDRAULIC
1 complaint
CAR TYPE: CHEVROLET AVEO 2005 MODEL: LS SEDAN WITH 14" WHEELS SINCE I PURCHASED THIS CAR IT HAS EXHIBITED VIBRATION IN THE FRONT END AND STEERING WHEEL WHILE DRIVING (ABOVE 50 MPH) AS WELL AS VIBRATION WHILE BRAKING. CAR WAS TAKEN INTO CHEVY TO BE REPAIRED. CAR STILL VIBRATES. UPON FURTHER RESEARCH I DISCOVERED THAT MANY OTHERS HAVE THIS EXACT PROBLEM. CHEVY HAS BEEN UNABLE TO FIX THIS PROBLEM. SIGNIFICANT VIBRATION WHILE DRIVING AND BRAKING (ESPECIALLY) IS A SAFETY HAZARD. SINCE CHEVY IS EITHER UNWILLING OR UNABLE TO FIX THIS SERIOUS PROBLEM I'M HOPING THE NHTSA WILL INVESTIGATE THIS PROBLEM. *JB
Oct 29, 2005
Frequently Asked Questions
How many problems does the 2005 CHEVROLET Aveo have?
The 2005 CHEVROLET Aveo currently has 235 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.
What are the most common problems with 2005 CHEVROLET Aveo?
The most common problems reported for the 2005 CHEVROLET Aveo are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.
Where does this 2005 CHEVROLET Aveo problem data come from?
All problem and complaint data for the 2005 CHEVROLET Aveo comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.
Other Years - CHEVROLET Aveo
2024 Problems
2023 Problems
2022 Problems
2021 Problems
2020 Problems
2019 Problems
2018 Problems
2017 Problems
2016 Problems
2015 Problems
2014 Problems
2013 Problems
2012 Problems
2011 Problems
2010 Problems
2009 Problems
2008 Problems
2007 Problems
2006 Problems
Other CHEVROLET Models
Similar Brands
ST
3,555 models
RS
3,484 models
NC
2,822 models
ND
2,385 models
Z
1,951 models
MOTO
1,583 models
NU
1,189 models
RC
1,122 models