2018 CHEVROLET Volt Problems & Complaints

On [XXX], while traveling on [XXX] near Rockingham, NC, the car suddenly decelerated, all of the dash warning lights came as well as a 'Reduced Propulsion' message, stop driving the car immediately. We did, called a tow truck, waited an hour and was towed to Diffenbach Chevrolet in Rockingham. They found multiple trouble codes and a bulletin saying the EGR valve needed to be replaced. (As it happens, these have been on a nationwide backorder for years.) The technician cleaned the valve and the car limped home after it sat at the dealership for a few weeks. BTW, we missed the Iron Maiden concert we were headed to Charlotte for. We then had the car towed from Southport, NC, to Jeff Gordon Chevy in Wilmington, NC. They had it for a while and stated the part was on back order and with no ETA. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Ten mile trip with 60% battery charge (about 30 mile range indicated, full tank of gas). Check engine light appeared. "Propulsion Power Reduced" appeared and cleared after restart at traffic light. Total loss of power at highway speed, "Shift to Park" appeared. "Power Off" appeared on energy display, coasted to shoulder and was unable to restart vehicle after multiple attempts.

Driving down interstate when the following error came up on the console: ACTION REQUIRED: SHIFT VEHICLE INTO PARK Coasted to a stop in the middle of a homeless encampment under the freeway. I was in fear of my life due to the failure of the vehicle. Vehicle taken to Rydell Chevrolet 18600 Devonshire St, Los Angeles, CA 91324. Told the Power Inverter Module had failed. Parts unavailable.

The car lost propulsion while driving on the interstate, luckily the car was able to make it the shoulder. The check engine light was not on prior to this and it was taken to the dealership where it diagnosed as a faulty battery energy control module (BECM). The part is awaiting replacement, but no spare parts are currently available.

The contact owns a 2018 Chevrolet Volt. The contact stated that after coming to a complete stop and shifting into park(P), the message "Shift to Park" was displayed. The contact stated that the transmission shifted to park(P) after several attempts to park the vehicle. The contact then turned off the vehicle. The local dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed nor repaired. The failure mileage was 25,000.

The contact owns a 2018 Chevrolet Volt. The contact stated that while attempting to start the vehicle, the engine failed to turn over as intended. Additionally, the vehicle would not charge when connected to a charger. The check engine warning light illuminated. The vehicle was taken to a local dealer, where the BECM was reset. The vehicle was repaired; however, the check engine warning light remained illuminated. In addition, the contact stated that the message "Reduced Power" was displayed on the instrument panel. The vehicle was taken back to the same local dealer where it was diagnosed, and determined that the BECM needed to be replaced. The vehicle was not repaired due to the cost. The contact related the failure to an unknown Chevrolet recall; however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 129,000.

When shift lever is moved to Park, the car often does not recognize it is in Park and can't be shut down. It takes a lot of time of moving the selector in and out of Park to finally get the car to recognize it is in Park. During an occasion when the car would not go into Park, the car ran for hours while the driver was at work. This seems to be a known issue (micro switch) with this model. This is available for inspection upon request. Safety is at risk because this condition leads to not being able to shut the car down, which leads to the potential for a dead battery and getting stranded. While I have not yet had my car's problem reproduced or confirmed by a dealer or independent service center, there is a lot of evidence in online forums of the prevalence of this problem. The vehicle/component has not yet been inspected by the manufacturer, police, insurance representatives or others. There weren't any warning lamps, messages or other symptoms of the problem prior to the failure as long as we've owned the vehicle. We purchased this vehicle less than a week ago, on August 2, 2025. The issue presented itself once on our test drive and again intermittently in the six days we've owned the vehicle.

When the vehicle is running, and the gear is moved to park, and I attempt to turn off the car by pressing the ignition button, an error shows on the dash display and the message is "Shift to Park". Even though the car is in park, the vehicle doesn't know it. I then cannot turn off my car.

Reduction of power , impossible to charge the kilometre says 21 kkm drops from 21 to 0 and the mountain settings dont run, I drive on maintenance , when charging at paying station does not charge,

When putting my car in park and shutting it off the dash board tells me to shift to park, and car does not fully shut off.

Component: Battery Energy Control Module, available from dealership ATM Daughter's safety compromised when vehicle power decreased quickly to 5mph in the middle of fast heavy city traffic. The problem has been confirmed by Chevrolet dealership service department The vehicle has not been inspected by other than dealership service center. I contacted GM, and was told that the component was replaced once already in 2021, so they will not replace it a second time on special coverage N232432680 released March 6, 2024. Warnings:Propulsion 11/3/25 Power Reduced and check engine light on 11/3/25. GM dealer service center cleared codes, did a software update 11/7/25: Propulsion Power Reduced and check engine light again. Vehicle is at GM dealer service center.

Chevy had done an update for the Propulsion Power being reduced. In 2024, I had to do another update when the check engine light came on. After that the electric battery power decreased, I am only getting 17 miles per charge. August 2025, the check engine light came on again. I had it check and no codes came up. While driving home on the freeway, the Propulsion Power being reduced warning came up. I had to pull off the freeway. Once I turned my vehicle off, I was unable to drive my car. There was not any acceleration. I had to have my car towed 50 miles home. A mechanic was able to repair it at that time. On 10/7/2025 the check engine light came on again and once again no codes appeared, on 10/14/25 the Propulsion Power being reduced warning came on again. I was able to get home safely, but I got off the freeway and took side streets home. At this time, the vehicle will not accelerate.

In 2020, GM issued a recall (#N192273600) for emissions pipes on the Chevy Volt that could be compromised by rubbing against the A/C hose connector. I took my vehicle to my local dealership (Chesrown Chevrolet) to have this issue remedied, that same year. This year, my check engine light came on and this same dealership informed me that the cause was this same issue (i.e. a compromised emissions pipe due to rubbing against the A/C/ hose connector). Assuming the fix was conducted per GM's specs, GM did not provide an adequate fix for their faulty design.

BECM module is failing producing a reduced propulsion message. This is happening while driving which is a safety issue. Limiting the ability to drive, handle and brake with the vehicle.

Vehicle produced error without any warning about propulsion system no longer working shortly after low fuel warning when tank is fuel and engine fails and vehicles comes to a crawl.

Battery failure is still under warranty but they don’t make batteries any more

Shift to park issue. Known issue with 2018 Volts but dealer is charging diagnostic fee when they know it is the issue because it displays shift to park when you try to shut car off. There is a bulletin stating this 19-NA-206. It states the Voltec warranty covers this but dealer states it is not. Dealer is West Herr Chevy, East Syracuse. Had to wait two weeks with the problem and then they left me stranded at the dealer ship because they did not fix it. This dealer had computer issues and sent service home early and left me without a ride home when I returned. GM needs to notify these dealerships that this problem is covered.

My 2018 Volt had a reduced propulsion power message and stopped running on its ICE in early Oct 2023 and because the battery was dead the vehicle wouldn't run at all. The next day 10-3-23 I was able to charge the battery and then brought the vehicle to the dealer for diagnosis. The problem seems to be with the EGR valve and the dealer ordered one at that time. It's been 3 1/2 months and there is no sign of the part. The car is only usable for its 55 mile all electric range which is often not enough but our family by borrowing cars and getting taxi rides and taking buses. This is by most measures unacceptable.

My car is demonstrating a "shift to park" error when I put it in park, which means I cannot turn off the vehicle fully. I am concerned I will be stuck somewhere if this issue is not fixed. It appears to be a known problem at GM and they irregularly cover it under warranty. It should be a recall issue that is fixed for free because it is a problem.

- Shift to park issue when the shifter is in park position and sometimes it will turn off. - Safety is at risk, this might still move or run even it is in park position. - Dealer will not take as manufacturer's defect. - They have not inspected the issues, but I will have to pay the diagnostic first and dealer will charge me with its repair. - The warning message appeared on the panel " Shift to Park."

My wife and I were on a 200 mile trip and the engine failed about 150 miles into the trip. Was driving and the instrument panel indicated that the engine was in reduced power mode. I switched over to battery power but had only approximately 10 miles of range left so after a couple of miles I switched back to engine power and was almost immediately informed by the instrument panel that the engine was in failure mode. Was fortunate that there was an exit nearby and was able to use the remaining battery power to exit the highway and pack the car before there was no power.the car was towed to a dealer and we were told that the egr valve and cooler had failed.they were replaced and I was told that they were not covered by the federal emissions warranty so the cost would be $4000.the car was driven with the vast majority being electric power.

The EGR valve clogged, causing a a servo to blow the F3 fuse, disabling the engine while driving. This occured suddenly while driving on a busy road with no shoulders. I managed to coast into a parking lot not too far away but I had no charge left in my battery. I could only get the engine to start back up for less than a minute at a time. I got my car inspected by Chevrolet and they confirmed they issue. Very shortly before the engine cut off, the car started jolting. There weren't any warning lights or error codes before this.

The dealer reported having repaired an emissions recall for a fuel vapor leak, however the repair was ineffective and the vehicle still reports the leak as a fault code "slow" and "fast" emissions leak. The dealer refused to recheck their work without payment. Recently I came into possesion of a borescope camera and was able to photograph the dealer's "repair". The photos clearly show the parts for the emissions repair are located in the wrong place as compared with GM's own service bulletin. Therefore the dealer did not do the repair, or failed to do the repair, and refused to check there own work without compensation when informed of the continuing problems and left me to do their recheck of their work at my own expense. I have provided photos of the GM prescribed parts placement and the incorrectly placed parts in my car as well as the resulting damage. We never experienced the relief intended to be provided by the repair service. They claim to have performed the necessary recall service, but THAT IS A FALSE CLAIM. See Chevrolet TSB N192273600. NOT PERFORMED CORRECTLY SO FAILED. The dealer, Haselwood Chevrolet, Bremerton Washington, was contacted by phone and email but offers no response. They have the pictures of the botched repair job. Additionally the car needs warranty service for a bad park switch which service they refuse to perform without my agreeing in advance to pay for that in warranty repair.

The contact owns a 2018 Chevrolet Volt. The contact stated that while driving at an undisclosed speed, the vehicle lost automotive power. The check engine warning light illuminated. Shortly afterward, the message "Reduce Propulsion, Engine will not Start" was displayed on the instrument panel. The vehicle was towed to a local dealer where it was diagnosed with a defective EGR valve. The contact was informed that the EGR valve needed to be replaced. The vehicle was not repaired due to the cost and lack of parts availability. The vehicle was towed to the residence. The contact believed that the cause of the failure was related to high temperatures. The manufacturer was made aware of the failure. The failure mileage was approximately 69,000.

I was driving and a message "engine popuslison reduce" appeared and i was not able to drive at the speed of traffics which was unsafe.

The contact owns a 2018 Chevrolet Volt. The contact stated that while the vehicle was parked and shifted to park(P), the message "Shift to Park" was displayed on the instrument panel and the vehicle was inoperative. The contact stated that the vehicle was operative while in low power mode; however, the vehicle intermittently failed to charge in low power mode. No warning light was illuminated. However, the vehicle displayed the full battery icon on the display, but 1 EV Mile. The vehicle was taken to an independent mechanic where it was diagnosed that the battery energy control module needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 11,000.

My 2018 Cheverolet Volt stopped charging via the PHEV port, the check engine light came on, and "Propulsion Power Is Reduced" read on the driver display. Car acceleration began to lag and I called the dealership service department immediately. I took it to the service dept and they said the repair is under warranty but the part is back-ordered with no ETA on when I will get my car back, but I should keep it there to prevent from getting stranded. They will provide no loaner car. It is currently at the dealership and I have no transportation. This appears to be a BECM issue.

The gear shifter for the Chevy Volt has an issue where it does not register in Park. I need to contantlty move through the gears to have it be in park.

When shifting to Park, and switching the car off, the vehicle will not register as being IN “Park”… and Displays “Shift To Park” and accompanying warning chime. Further, the car will not turn off.

When turning vehicle off, it will display a message "SHIFT TO PARK" even though shifter is in the park position, the vehicle will also remain on. Sometimes have to jiggle the gear shift or shift back into park a few times before the message goes away and am able to turn vehicle off. This is very dangerous as if it's left unnoticed in a garage the car can be left running potentially filling the house with fumes. Can also run out the battery and gas and leave you stranded if away from your home.

On June 27, 2025, while driving, the vehicle displayed a "Propulsion Power Reduced" warning message and a Check Engine Light illuminated. I immediately experienced a loss of power. I brought the vehicle to an authorized Chevrolet dealer the same day. On July 1, 2025, the dealer diagnosed the failure as a faulty Battery Energy Control Module (BECM) and high-voltage system fault (Code P1E00), requiring a full replacement of the high-voltage battery pack (Part #24296900). The manufacturer (GM) was contacted, and the replacement battery was ordered on July 2, 2025. As of December 2025, the vehicle remains in dealer possession (over 5 months) with no repair completed. The manufacturer has stated the part is on indefinite backorder with no ETA. The failure of this component renders the vehicle inoperable and presents a safety risk due to sudden loss of propulsion power while in motion. The manufacturer has confirmed the failure but is unable to provide a remedy within a reasonable timeframe.

The car can't decide if it wants to use the battery or the engine. It shows zero charge even though it is full. It lurches at stop lights as it tries to decide whether to use battery or engine. It says "propulsion power reduced". "Not able to charge". "Shift to park". Check engine light is on.

The BECM (Battery Electric Control Module) failed in November of 2023. Mountain Chevrolet has had my vehicle since then, claiming to be unable to find replacement battery module. The vehicle is available for inspection at Mountain Chevrolet (it has been left unlocked, unprotected, and exposed to the elements for almost 15 months now). When the BECM failed, the vehicle lost virtually all power and slowed dramatically from highway speeds to ~20 mph. There were no warnings prior to the failure.

On [XXX] while driving with my son in IN on [XXX] to my niece's wedding in PA, a reduced power warning sounded on the driver's console. Was able to stop and get gas at the eastbound travel plaza near mile marker [XXX]. Getting back on the road and accelerating toward 70 mph, suddenly lost all drive power. The fuel gauge side of the console was lit in yellow and said something like "No fuel detected." Pulled over to the shoulder and found the engine would start, run, and then die. An IN State Police Officer was kind enough to offer us an escort to the next exit near mile marker [XXX]. Noticed that the engine would remain running for longer periods and finally stayed on continuously. While being escorted, was able to run the speed up to 55 mph and made it safely to the interstate exit. During this time my son was checking online and found that the problem might be due a blown fuse. At the [XXX] exit we found a Pilot station that carried fuse sets. One of the sets had the fuse we needed. We bought two sets. We replaced the fuse--it had blown--and the car ran well again. This fuse is called "No walk home." We were able to continue on at 70 mph until stopping at a friends home in western PA for a few hours rest. While at our friend's home we partially charged the Volt's battery giving us about 20 miles of electric range. While in electric mode we stopped for gas. We drove through the mountains without incident then stopped for gas again in central PA at the Cumberland Valley Service Plaza. Filled the tank and while accelerating from the plaza again lost power and had to pull over. Replacing the fuse solved the problem once more. It appeared that turning off the engine while in gas mode and then turning the engine back on leads to the fuse blowing. That Sunday on the return trip to IL, I never turned the car off when refueling. This got me back home without incident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

After getting some repeated "propulsion power is reduced" display warnings, my 2018 Chevrolet Volt literally died without warning while I was driving it on New Year's Eve and could not be restarted.

Why in operation the car goes into Shift to Park and Also getting a Propulsion Power Reduce

Our Volt EGR valve has gone bad and car not drivable. They claim these have been on back order (very expensive) for a year! They also say it's NOT part of emissions! WTH? Car gas 36k HELP!!

Lost propulsion power went from doing 75mph to 35mph on the fast lane with no warning vehicles swerving to avoid hitting me..very scary and dangerous 3rd time this happens I now try to avoid fast traffic.. please look into this someone going to get hurt if no action taken..

After recent repair of hybrid transmission, experienced a loss of power, MIL, and several trouble codes related to the battery control module (BECM). This affects safety as the loss of propulsion unexpectedly causes deviations in speed from typical traffic flow. The problem was confirmed by OnStar and a manufacturer representative was advised with a dealer appointment scheduled when they next open. There were no lamps or other symptoms prior to this MIL and loss of power. Restarts after shut down have not been attempted until able to take the vehicle to the dealership.

"Propulsion power reduced" message along with check engine light, loss of propulsion power from battery, loss of ability to charge battery. OBD2 scanner reveals P1E00, and 12 U26xx fault codes relating to Battery Energy Control Module failure.

On May 26, the car was running in electric mode and switched to gas because the power batteries were depleted. Shortly after switching to gas mode, lights came on the dash board saying Engine Not Available Get Service Immediately. I was on a highway at the time and fortunately had just enough left to get off and the car would not move any further. Turning the car on and off did not resolve the problem. It had to be towed to a Chevy dealer. Even after an hour, the messages would come on when trying to start the car. The next day, the dealer called and said they could find no problems with the car and it works fine. This happened once before, but that time there was enough charge in the battery to get home and then later it would start without the message.

Driving on gas on the highway, the adaptive cruise control suddenly disabled with a "Reduced Propulsion" message on the dash and a check engine light. The car started struggling in its propulsion. We found an AutoZone and scanned the codes, and multiple were returned. A Google search pointed us to the "walk home" fuse, which indeed had been blown. Replacing that fuse and disconnecting/reconnecting the battery eliminated the errors. Less than a week later during highway driving (the next time the battery charge was used up and it switched to the ICE) I got another check engine light, but this time without the "reduced propulsion" message. Scanning at AutoZone again revealed a P0404 message referencing the EGR valve. Due to the limited availability of the part I have called into Covert Bastrop (Bastrop, TX) and am waiting to hear back on their ability to fix the car.

While driving our 2018 Chevy Volt, dashboard warning message “Propulsion Power Reduced” displayed. Vehicle performance was not otherwise affected. Subsequent diagnosis from our Chevy Dealer was, among other things, a faulty Exhaust Gas Recirculation (EGR) valve. We were informed that our vehicle was “no longer safe to drive in this condition” and the vehicle has been sitting on the Dealer’s lot awaiting a replacement part for 2 months and counting, with no expectation of near-term resolution of our problem. We are aware that this is a widespread problem on 2017-18 Volt models, with many dissatisfied owners.

In June of 2023 the car experienced propulsion power reduction. The car was at the dealer awaiting repair for 3 weeks. On Dec. 14,2023 the same thing happened again. The car was also unable to accelerate once mobile. The car has about 90k miles on it.

Car died while driving down road. Has engine codes to service high voltage system although It showed a full battery it only had 1 mile range and the gas motor wouldn't run.

Early on the week of November 9th my car displayed a message that there was "Low propulsion power - engine not available." Upon returning home and parking the car it started without incident the following day. On November [XXX], my vehicle stated "Low propulsion power - engine not available" but this time the car shut down completely leaving me unable to return home. I had the car towed to Fairway Chevrolet for repairs. The service technician indicated that the catalytic converter needed to be replaced and the part was out of stock and would take 3 weeks to become available. No rental or loaner car was provided. On November [XXX] I was told that my car was fixed and it would be able to be picked up. I picked up the car and parked it at home and drove the car I was currently renting to California for the Thanksgiving holiday. Upon returning home, I returned my rental and returned to my car. The car behaved normally but after driving down a busy roadway for less than 2 miles the "Low propulsion power - engine not available" message reappeared and the car shut off IMMEDIATELY. This is horrifyingly dangerous especially considering the speed and location of where I was driving. I had the car towed to Fairway Chevrolet but didn't speak to anyone until the morning. In the morning I called in and explained what happened and stressed the safety fact that my car was returned and malfunctioned in a very dangerous way. The tech said that they were going to perform a diagnostic which they were going to charge me for, even though the original repair did not fix the defect. Fairway performed the diagnostic and stated they need to clean the engine bay and run a separate diagnostic of the brake system. These total more than $1.6k out of pocket and are not related to the power deactivating while in motion. My car is still at Fairway as they have not started the repairs and I am still self paying for a rental car. Fairway is uncooperative and refuse to check into the propulsion INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Initially was receiving intermittent “Recieved Propulsion Power” warning and no check engine light. Did it about every 2 weeks but became worse. Received Reduced Propulsion power warning on a road trip from East TN to Charlotte then showed a check engine light. I continued to Charlotte I had 4 miles left on battery and was running on gas engine when “Engine Not Available” warning came on leaving me with a nearly dead battery for propulsion. Fortunately, there was a very nearby GM dealership in Charlotte which I was able to drop off and flew out of town for the week. I was told by the dealership that it was an O2 sensor and they had replaced it. Picked up the car the next week. I began the 3 hour trip back to East TN and about 30 miles into the trip I received the Reduced Propulsion Power AND Engine Not Available. I had about 10 miles left on the battery so I stopped and stayed at a hotel with a car charger overnight. Resumed trip home that am, but same code was displayed and engine would not come on. Rented a uhaul w/trailer and towed it home. Dropped it off at Champion Chevrolet in Johnson City and they diagnosed it as a faulty EGR valve. I learned that the part has been back ordered and looking at web forums I see people have described the same problem and they have been waiting many months for an EGR to be available. So, nature of complaint is: I got lucky in that I did not get stranded. Fortunately I was in the right place at the right time. I could have easily totally lost propulsion were my battery were fail and don’t know if I could have gotten off the roadway.

The vehicle has a failure of the BECM and the EGR valve and cooler. Both parts are unavailable. I've been without my car for over a month. The service center cannot tell me when parts will be available.

While driving my 2018 chevy volt I received a reduced propulsion error. I pulled over to assess and turn off the car and turn it back on only to find when I turned it back on I received an enginer failure error and the car would not drive forward or reverse. I had to have it towed to a Chevy dealership for evaluation. I understand from research and talking to service experts this is a common failure among the 2017 and 2018 Chevy volt and it is abhorrent that Chevy has not issued a recall on a common failure that compromises the safety of the driver and other drivers around them.

Reduc d propulsion power warning while driving in EV mode. ICE started and was able to make it 1/2 mile home. Failure diagnosed to a faulty BECM. Has been at the dealer for 1 month today with no word on when the part or repair will be done.

Front brake calipers are sticking on, causing the brake pad to engage the rotor causing excessive heat. Risk of fire when parked in garage. I have had the calipers taken apart and cleaned and greased and still have the issue. I have read many reports on message boards of the same issue with no fix.

Main Issue: Ongoing issue with stuck caliper causing the pads and wheels to overheat increasing the tire pressure to dangerous levels. The regenerative braking system is actually very effective in slowing the car when driven in L mode. If driven smartly, driver rarely have to use a lot of force using the physical brakes and rotors. Three times now, I have had issues where the front calipers were seized and the brakes were stuck causing the wheels to have visible smoke, odors and extreme temps. Perhaps they are not being used as much as normal brakes but service was done at the dealership on both cases, only to have the issue return within a year on a low mileage car. Looking at online forums, this appears to be a common issue with the Volt. Often the High Pressure Accumulator (HPA) is not properly reset during a brake job. [XXX] I have had other non EV cars with regular brakes that worked fine for > 50k miles before service, so there is clearly an issue here. Ironically, as these brakes caliper/pistons/rotors are less used due to regen, the chance of them getting stuck seems to be an issue when they are actually engaged leading to dangerous conditions. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

abs system failure due to defect The cause of the condition may be a fracturing of the front half shaft anti-click washer (1) and possible collateral damage to the ABS wheel speed sensor (WSS). this defective $5 part causes thousands of dollars of repair this should be a recall as there are numerous reports of these parts failing and causing the vehicles braking system to be impaired this failure has happened to this vehicle 2 times with in the last 60 days

GEN 2 VOLT HAS A PADDLE ON THE STEERING COLUMN THAT BRAKES THE VEHICLE AND ADDS SOME CHARGE TO THE MAIN BATTERY. (PART OF THR REGEN SYSTEM) SINCE IT BRAKES THE VEHICLE I BELIEVE THAT THE BRAKE LIGHTS SHOULD ILLUMINATE , THEY DON'T . IN THE OWNERS IT STATES THAT THE "BRAKE LIGHTS MAY COME ON"... MAY???..... I HAD THE VEHICLE IN THE DEALERSHIP FOR 2 DAYS. THE BCM WAS CHANGED AND THAT WAS SUPPOSE TO FIX THE ISSUE, IT DID NOT. I AND OTHER VOLT FORM MEMBERS FEEL THIS AN UNSAFE CONDITION. 17/2018

COLLISION OCCURRED ON E DENNY WAY IN SEATTLE, APPROX 3:20 PM ON A DOWNHILL SLOPE IN STOP-AND-GO TRAFFIC AFTER ABOUT 20 MINUTES OF CONSTANT BRAKE USE TO HOLD BACK THE CAR. ABOUT 2/3 OF THE WAY DOWNHILL THE BRAKES FAILED, NO RESISTANCE WHATSOEVER AND THE CAR ROLLED INTO THE VEHICLE IN FRONT, A DISTANCE OF ABOUT 15 FEET. THIS WAS A ONE-OFF INCIDENT AND DID NOT RECUR SO FAR. GM AND 3RD PARTY INSPECTORS FOUND NO ERROR CODES, BUT THE BRAKES INDEED FAILED, WHICH MAKES ME SUSPECT A DESIGN PROBLEM IN THE BRAKE-BY-WIRE SYSTEM THAT CONTROLS THE PEDAL PRESSURE AND MODULATED REGENERATIVE BRAKING. IT WAS LIKE SLIDING ON ICE, NO TRACTION WHATSOEVER.

Electrically actuated EGR valve fails, it draws too much current and blows the F03 fuse (Labeled “No Walk Home”) which has 4 other components on it, this causes “Reduced propulsion” message, soon after the engine overheats due to one or more of the 3 other components that lost power, and the “Engine not available” message appears and the vehicle loses all motive power. This syndrome is well documented in the GM-Volt online forum. Additionally this vehicle has portions of the EV battery that failed, I am still waiting for battery parts to arrive and its been 4 months, many owners have waited between 1 and 2 years for the battery to be fixed, this contributed to this issue as the electric propulsion would have possibly been available if the warrantied battery was repaired within a reasonable timeframe. I was refused a service loaner. My recent contact with Chevrolet customer service suggested I rent a car, and they will reimburse $45 per day, however they insist I pay for it and when the repair is complete, they will reimburse me. There is a gentleman on the Volt forum who has laid out about $5,000 on rental cars for well over a year, and is finally reluctantly getting a buyback, but they depreciated the car but did separately make good on the rental reimbursement. Neither he nor I really want that result, we want the car repaired in a good faith effort, instead both battery parts and EGR valves are in short supply. Currently the GM part is between $1400 and $2500 when in 2024 the same part was widely available for $240. I understand this is a bit rambling, but the context matters, and GM is dragging their feet on servicing the warranty liability they have. My TZEV warranty is good until 2034 and they are actively trying to kill my car off to save the ongoing cost of servicing this warranty. They are also putting owners at risk. Please consider a battery recall and an EGR valve recall. Regards, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

EGR valve failure at highway speed of 70mpg on busy road with passenger and service dog in vehicle on a road trip (on ICE not electric). This produces a reduced propulsion in the vehicle and it becomes unsafe to drive. The EGR failure blew the 15A #3 fuse known as the "no walk home" fuse, so I needed to be towed to a parts store then unplug the EGR valve to make it somewhere safe. It was a Sunday, so every dealership (in the VA area at least) was closed. It is a well known/documented issue and the warranties have been extended, but only in a few states with the CARB protections. There are no warnings, if I was not an adept driver, we could all be dead. I also became stranded ~six hours from my home and only ~eight thousand miles outside of warranty. The replacement part costs ~$1800 without labor - the most expensive EGR valve the 60yr old parts employee at the dealership had ever seen, on a hybrid car which doesn't even truly require the part to operate or to pass emissions in some states. I think GM will help me with a goodwill repair in this case, as I have been a loyal Chevy customer my entire life and Volt owner since 2013 - but that is not the norm, so please take action and extend warranty protection to all Volt owners like the BECM issue.

On 8/30/2024 I had driven my 2018 Volt (purchased new on 3/27/2019), with about 45,000 miles on it, on a normally 5 hour trip. About 3 hours into my trip on I-94 my car suddenly slowed down with a "Reduced Propulsion" message and a check engine light that came on. (The engine probably has run less than 25,000 miles of the total miles I have driven it, with the rest being purely on battery.) I was extremely fortunate to have been in the slow lane when the car suddenly stopped accelerating. This could have easily turned out very, very bad. The next day I had a dealer diagnose the car for a little over $400 - they told me there was a problem with my engines EGR valve and that the parts were back ordered so they couldn't give me an indication of when it could be repaired. I got the car back to my home dealer and they charged me another $200 to re-diagnose the problem and came the same conclusion of a bad EGR valve. They too have been unable to get a valve from GM. They have quoted me about $4,000 to have a new valve installed when they can get one. Heck, the car only has 45,000 miles on it!!

While driving on the highway, the EGR valve in my car malfunctioned, initially causing my dashboard to read "Propulsion Power is Reduced". After continuing to drive the car, the dashboard read 'Engine not available, service soon', where it stalled and we had to restart the car. After restarting, the car went into EV mode with significantly reduced speed. Our safety was put at risk due to the initial stalling and subsequent reduced speed on the highway. The problem has been reproduced since the initial incident and our dealership confirmed the problem relating to the EGR valve which continues to blow fuses when the engine is over-exerted while using gas. The dealership said that this is covered under warranty however, there has been a 5-year back-order on the part and they are refusing to offer any loaner car or compensation for a rental car.

EGR valve clogged and failed on a long trip, bricked the car and had to tow many miles back to home shop. now have been waiting 9 months and still no idea when the part will be available from Chevrolet. My shop and I have claims to Chevrolet for the part for service but still nothing and is getting so we are inconvenienced in travel.

My BECM failed pulling in to my grandpas house. I was able to park the car, but unable to start it afterwords. Prior to failure, the engine would switch between electric, then back to gas, then back to electric This is a very common issue on these vehicles. I am fortunate this did not occur on the highway, as I had just exited I 94

BECM failed upon startup. Pressed start and vehicle appeared to turn on. Shifted into reverse but there was no motor power and I began to roll backwards down the driveway. Started the vehicle again and then the engine came on and a reduced propulsion message appeared.

Shift to park defect. When I try to turn my car off it won’t completely shut off, a notification on my dash says “Shift to park” but my gear shift is in park already. It takes 5-10 times of me cutting car off and on for it to finally completely shut off.

Vehicle is 2018 Chevrolet volt with approx 91000 miles, purchased new in California with both PZEV and Voltec warranties in place. Vehicle produced MIL in December, in Colorado, with exterior temperatures ~30 degrees, after attempting to remote start. The resulting OnStar Codes P1AEE, P1AEF, and P0AC4 indicating "the electric propulsion system is not performing as expected. Please service immediately." Drove the vehicle to the nearest dealership assuming there could be an unexpected loss of power. Identified PIC6285B as trouble shooting aid for the dealership. The dealership stated they contacted their GM TAC representative and the service foreman and TAC agreed the vehicle needed a transmission flush. No indication that the work would be covered by the bulletin found. Customer contacted Chevrolet EV advisor and confirmed vehicle did not qualify for any warranty as the diagnostics indicated a category 4 issue associated with the bulletin but the repairs required were a transmission flush. This was contrary to the published bulletin, other customer reports, as well as the specific DTCs expected. Customer believes diagnostics would be covered by bulletin or warranty given a repair was identified based on the trouble codes that were pulled. Dealership and GM did not agree with customers belief. Customer forced to pay in order to recover vehicle after 1 week.

WILL NOT SHUT OFF WHEN TRANSMISSION SHIFTED TO PARK.

VEHICLE WILL NOT SHUT DOWN PROPERLY. WHEN TRYING TO TURN OFF PUSH BUTTON IGNITION THE VEHICLE SAYS " ACTION REQUIRED: SHIFT TO PARK". THE VEHICLE IS ALREADY STOPPED AND IN PARK HOWEVER IT IS NOT REGISTERING SOMEHOW.

WHILE ATTEMPTING TO TURN THE CAR OFF- A MESSAGE APPEARS SAYING "ACTION REQUIRED- SHIFT INTO PARK". THE CAR IS IN PARK AND THE DASH REGISTERS THAT IT IS IN PARK, THE GEAR SHIFT IS LOCKED IN PARK BUT THE SYSTEM DOESN'T SENSE THAT IT IS IN PARK AND WON'T LET THE CAR SHUT OFF. HAS PROGRESSIVELY GOTTEN WORSE AND MORE FREQUENT.

Dashboard displays “Shift to Park” message even when the shifter is in the park position for the past month. I am unable to turn off the vehicle completely until I Shift to drive then back to park multiple times.

When placing in park it doesn't trigger the switch and car will not shut down.

"SHIFT TO PARK" WARNING ALERT ISSUED WHEN SHIFTER IS ALREADY IN PARK. THIS ISSUE OCCURS INTERMITTENTLY AT LEAST 3X A DAY. WIGGLING AND/OR RESHIFTING TO PARK SOMETIMES RESOLVES THE ISSUE. MORE EFFORT AND TIME TO "PLAY" WITH THE SHIFTER IS REQUIRED IN THE LAST MONTH TO MAKE THE WARNING GO AWAY. ONLINE RESEARCH RESULTED IN MULTIPLE REPORTS INCLUDING VIDEOS ON THE ISSUE WITH THE SHIFTER ASSY. THIS ISSUE STARTED OCCURRING WHEN THE CAR WAS 1.5YEARS OLD. THIS ISSUE SEEMS TO BE SYSTEMIC WITH OTHER SIMILAR GM MODELS. PLEASE CONSIDER ISSUING RECALL TO FIX THIS ISSUE. THANK YOU. *TR

The Volt experienced a "Shift to Park" error, preventing it from recognizing when it was in park, even when the gearshift was engaged. While this issue was frustrating, it initially didn’t affect the car’s driving capability. I simply had to wiggle the gearshift until the system registered that it was in park. This problem persisted for a month until one day, the vehicle would no longer shift into any mode, though the "Shift to Park" message remained on the dashboard. The car turned on but would not accelerate. The issue was eventually repaired at the dealership, a process that took about two weeks. During this time, we were not initially offered a rental car. It was only after we called and insisted that the dealership provided one while waiting for the necessary parts. This issue appeared to be a factory defect. While part of the repair was covered under warranty, we still had to pay $685 out of pocket.

When attempting to power down car after shifting into park, message states shift to park. Car cannot be locked or secured.

"SHIFT TO PARK" ERROR DISPLAYS AFTER SHIFTING THE CAR INTO PARK. WHEN THIS ERROR MESSAGE OCCURS, I AM UNABLE TO TURN OFF THE VEHICLE. *TR

On [XXX], while driving on [XXX] in Virginia, the check engine light came on in my Chevy Volt. A message on dash said that there was reduced propulsion, and the gas engine quit running. The car switched to battery power, which would not have lasted long enough to get us home. At this point, we were stranded on a very busy highway which seemed quite dangerous. Using battery power, we were able to get off the highway. We then made arrangements to have the car towed, approximately 150 miles to a car dealer/repair business in Frederick MD. The vehicle was checked out by the car dealer who identified the EGR valve as the problem. However, they did not know when the part would be available , and still, 4 weeks later, do not have any date for availability of the broken part. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

When I stop and shift vehicle into park and try to turn off vehicle. The vehicle does not recognize the vehicle is in park and will stay running. This had happened numerous times and is ongoing. Have read there is even a class action suit because of this problem with numerous different gm vehicles. Why has a recall not been issued?

VEHICLE WILL NOT TURN OFF ON A REGULAR BASIS.. RECEIVE A MESSAGE THAT READS: 'ACTION REQUIRED. SHIFT TO PARK.' WHEN THIS OCCURS, THE VEHICLE CAN NOT BE TURNED OFF OR LOCKED. RESEARCHED THIS PROBLEM ON THE INTERNET AND DISCOVERED THAT IT IS A VERY COMMON PROBLEM THAT AFFECTS NEARLY ALL 2016, 2017 AND 2018 CHEVROLET VOLTS. A RECALL SHOULD BE IMPLEMENTED!

while driving my vehicle when the outside temperature is 50 degrees Fahrenheit or below I turn my defrost on and for 30 plus seconds my front window completely fogs up and I am unable to see out of my front window and have zero visibility which caused me to crash.

There is a lot of interior chrome, something I have complained to GMC about before. Today it caused me to be temporarily blinded by the reflection of the sun at multiple angles preventing me from seeing other vehicles. I had my 3 year old daughter in the car with me as I was nearly killed because I could not [XXX] see. If my daughter had been hurt I would have lost my [XXX] mind because I TOLD GMC ABOUT THIS BEFORE!!!! Interior chrome is dangerous and needs to go. At a bare minimum they need to offer replacement parts and install for all this interior chrome. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The windshield washer tank was leaking fluid to the point that no fluid was available to clean the window. Upon repair it was found that a protruding screw had punctured the washer fluid tank causing the leak. The mechanic backed off the screw and added a rubber cap to the tip of the screw to hopefully prevent another incident.

My 2018 Chevy Volt was at a Chevrolet dealership in Burbank and they have been running tests on my car to re-create the problem which they have not been able to do. On [XXX] my car suddenly stopped and shakes violently after I turned it on after about driving 15 feet, and my screen was telling me “engine not available, service needed soon” so I got it towed to the dealership (no prior warning signs on dash or anything). On [XXX] they told me they were not able to find the fix or recreate it and also said “This is definitely very rare. Drive it around and bring it back in if it happens again” which felt like they really didn’t care for my safety at all. On [XXX], the same exact problem happened with my car, “engine not available, service needed soon” and shook violently (my girlfriend witnessed it) after 100 yards of driving it and then towed my car back to the dealership. On [XXX], 23 DAYS LATER, the Chevy dealership calls to tell me they still haven’t been able to recreate the problem or find a solution again. I haven’t been able to drive my car this whole time. I have had a case open with GM this whole time where they have been extremely spotty on communication and pretty much just ignoring me the alot of the time. They called me on Saturday, [XXX] (when they’re “closed”) to tell me their solution but I missed the call, I called Monday and Tuesday but can’t get in contact with my advisor until finally Wednesday, I call and they are able to connect me and they gave me a final solution on [XXX] of $1500 off a New GM brand car so they weren’t in any rush to contact me about the final solution. They should repurchase the car from me and pay for damages. Car feels extremely unsafe and there should at least be some type of diagnosis… CHEVROLET CANT FIX THEIR OWN CARS, UNREAL!!!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

When attempting to turn the vehicle off after parking, the driver's console displayed the message "Action required: Shift to Parlk". The shifter was already firmly in the "Park" position. Moving the shifter back to "D" and then back to "P" did not resolve the issue. Pressing the power button twice more resolved the issue this time without further moving the shifter. This is a well-known and well-documented issue with "Gen 2" Chevy Volts.

I LEASED A CHEVY VOLT 2018, ABOUT 3 MONTHS AFTER THE FIRST FEW CHARGE, USING THE CABLE THAT CAME WITH THE VEHICLE THE CAR DO NOT CHARGE ANYMORE, AIR CONDITIONING NOT WAS WORKING, I REPOSTED THE ISSUES TO THE SALES AGENT. HE RESPONDED THAT THERE WAS NOTHING WRONG WITH THE VEHICLE, THAT I NEED TO LEARN HOW TO USE IT. A COUPLE OF MONTHS LATER WHEN I WAS DRIVING THE THE VEHICLE STARTED TO SAKE AND THE CONTROL PANNEL WENT CRAZY, I CALL AGAIN TO THE DEALER. THEY TELL ME THIS TIME TO BRING THE CAR INN. AFTER THE KEEP IT FOR A DAY, THEY CALL ME TO SAID THAT THEY HAVE TO KEEP THE CAR BECAUSE THE CAR HAVE A DIFECTEC BATTERY CELL, THEY TELL ME THAT THEY NEED TO ORDER THIS CELD AND INSTALL IT. THEY KEEP THE CAR FOR A WEEK. AFTER THE CAR WORK OK FOR A COUPLE OF MONTHS AND AFTER THE AIR CONDITIONING NO NOT WORK, I CALL AGEING TO REPORT THE PROBLEM, BUT THEY GIVE ME THE SAME ANSWER. AFTER I RECEIVED A NOTICE OF A RECALL FOR THE AIR CONDITIONING, I TOOK THE CAR FOR SERVICE AND I NOTICED THAT THEY NEVER ROTATED THE TIRES AS THEY CLAIMED. THE PROBLEM WITH THE AIR CONTINUE, SO I TOOK THE CAR TO A DEALER CLOSER TO MY HOME, THEY TELL ME THAT THE CAR HAVE A PROBLEM AND THEY NEED TO KEED THE VEHICLE. AFTER THEY TELL ME THAT I HAVE TO PAID BECAUSE FOR THE REPAIRS ABOUT 1600.00 BECAUSE OF THIS PROBLEM I DON'T HAVE A CAR AND I'M ABOUT TO LOSS MY JOB. THIS CAR HAS BEEN A NIGHTMARE. I ASK THE DEALER TO PLEASE TO TAKE BACK THE CAR. I ALSO ASK CHEVROLET CORPORATION BUT NOT ANSWER HAS BEEN TAKEN, THIS CAUSE ME TO LOSS MY JOD SND CREATED MANY PROBLEM TO ME AND MY FAMILY. THE VEHICLE STILL ON THE SHOP FOR THE LAST TWO WEEKS AND THEY TRLL MR THAT MAYBE TAKE LONGER. CAUSE THEY DON'T HAVE THE PART AND THAT IS ON BACK ORDER.

The BECM on my 2018 Chevrolet Volt has failed and I am being told it may be months before the dealership will have the part to fix the issue.

On Dec 3, 2023 I got the message "Propulsion Power is Reduced" and the gas engine started even though there was about 53 miles left in the battery. I was able to continue on to my destination use the gas engine. On Dec 8, 2023 I drove the car to La Quinta Chevrolet and they diagnosed the problem as a failed BECM (Battery Energy Control Module). On Dec 11 I got the car back and was told the BECM is on backorder and there is no estimated delivery date. Also on 12/3 when I tried to start the car after getting it home I started getting the message "Shift to Park" The dealer was able to fix this before I got it back on 12/11. I've been told I don't qualify for a loaner vehicle so I am left with a car that could stop at any time.

BECM (Battery Energy Control Module) failed. Initially received check engine light, reduced propulsion power, and battery not available warnings but was able to drive via the internal combustion engine. Within 24 hours, car was completely dead in my driveway and would not drive at all on either propulsion system. Ended up having to have it towed to the dealership where the faulty BECM was diagnosed and replaced under warranty.

The contact owns a 2018 Chevrolet Volt. The contact stated while driving 65 MPH, the vehicle sputtered and independently turned to the right. The contact was able to pull to the side of the road and became aware that the vehicle was smoking. There was no warning light illuminated. The vehicle had not been diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and determined that the VIN was not included in a recall. The failure mileage was approximately 80,200.

POWER STEERING FAILED WHILE DRIVING INTO BALTIMORE CITY ON I-95. WAS ABLE TO CONTROL THE VEHICLE WITHOUT POWER STEERING BUT IT WAS DIFFICULT. THE POWER RETURNED AT THE END OF THE WORK DAY AFTER THE VEHICLE DID NOT MOVE ALL DAY. TOOK THE VEHICLE TO THE DEALER. THE DEALERSHIP SAID IT FOUND "SCAN CODE C056D FOUND BULLETIN 18-NA-313".

LOSS OF POWER STEERING WHILE DRIVING. ERROR MESSAGE ON DASH AS WELL. VERY DIFFICULT TO TURN AND NOT POSSIBLE TO MAKE A QUICK AVOIDANCE. HAD TO HAVE CAR TOWED TO THE DEALERSHIP. DEALERSHIP FOUND DTC ERROR CODE BUT COULD NOT DUPLICATE THE POWER STEERING LOSS. DEALERSHIP DID NOT REPLACE OR FIX ANYTHING AS OF NOW.

When the Gear shift is placed into park and the power button to turn the car off is pushed, I get an alert that says “Shift to Park” and cannot turn the car off. I have to attempt to turn the car off and on several times before I can actually turn the car off and leave it.

Car will not shift to park. Will not allow the car to be turned off.

TL* THE CONTACT OWNS A 2018 CHEVROLET VOLT. WHILE DRIVING 55 MPH, THE VEHICLE JERKED FORWARD VIOLENTLY, SLOWED DOWN TO 45 MPH, AND THEN STALLED. ALSO, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE CONTACT IMMEDIATELY POWERED OFF THE ENGINE IN THE MIDDLE OF TRAFFIC. THE VEHICLE WAS PUSHED OVER TO THE SIDE OF THE ROAD BY THE POLICE AND TOWED TO MAHER CHEVROLET (LOCATED AT 2901 34TH ST N, ST PETERSBURG, FL 33713). THE DEALER FOUND SEVERAL FAILURE CODES AND THE TRANSMISSION FLUID PUMP OUTLET SEAL, INTERNAL FILTER, AND SPACER PLATE WERE ALL REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED CASE NUMBER: 9-5251855943. THE APPROXIMATE FAILURE MILEAGE WAS 12,125.

On [XXX], our 2018 Chevy Volt experienced a critical BECM (Battery Energy Control Module) failure while being driven by our [XXX] daughter. The failure caused the vehicle to enter limp mode, resulting in a severe loss of power and the inability to shift properly. Most alarmingly, the brakes failed to function correctly—despite being fully engaged, the car continued to move forward at a red light, placing our daughter in immediate danger. She was only able to safely stop the vehicle by maneuvering it off the road into a parking lot. This BECM defect is a well-documented issue for Chevy Volts from 2016 to 2018. However, Chevrolet has refused to cover our VIN under the existing special service bulletin, despite our vehicle using the same faulty part number as those included in the recall, and has provided no explanation for this exclusion. As a result, we are being forced to pay $2,100 out of pocket to replace a part that GM knows is defective. This is an unacceptable financial burden for a safety-critical issue. GM should immediately issue a recall for all vehicles equipped with this faulty part number to ensure the safety of all drivers and prevent further undue costs. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2018 Chevy Volt has experienced the GM knows BECM issue. There are several Volt Owners that have experienced this issue. I would like to bring this to the attention for GM to post a recall/mandatory service repair as my car stopped working, would not start, was displaying false information on the electrical module, etc. Issue: 1. Car would not start 2. Battery stated fully charged with solid green light but display showed only 1 electric mile available 3. Tried to shift car to Reverse press gas nothing happened 4. Tried to shift car to Drive press gas nothing happened. 5. Car engine light is on 6. Utter confusion as stress as I’m stranded with no way to get my car working 7. Chevy dealership has had my car for one week now with the only update of ordered BECM module. No ETA on when this will be fixed 8. No indication of what caused the issue

A Shift to Park message displayed while the vehicle is in park. The car will not turn off and continues to run. The issue is well documented through GM/Chevrolet, as they have a service bulletin (19-NA-206) for it. That document specifically states that the Voltec Warranty covers this issue, but Chevrolet is refusing to service my car based on its VIN number, despite identifying it as the same issue. And for the last question, no lights initially came on but then the check engine light came back on. When the car was finally turned off at the dealership, it turned back on with no issue lights or messages.

After I put the car in park, the car dashboard doesnt reflect this change, essentially assumes the car is not in park and I am unable to lock the car and the lights will stay on for a while. After jiggling the shift handle just the right way I could get it to recognize the car was indeed in park.

The contact owns a 2018 Chevrolet Volt. The contact stated that the battery module became inoperable. While attempting to start the vehicle, the message "Engine Unavailable - Service Soon” was displayed. The contact was unable to use the vehicle. The contact stated that the TPMS warning light was illuminated. The contact associated the failure with Technical Service Bulletin: 18-NA-261. The contact called the local dealer and was referred to the manufacturer for assistance. The vehicle was not diagnosed or repaired. The manufacturer was contacted and confirmed that the VIN was not under recall. The failure mileage was approximately 111,000.

The contact owns a 2018 Chevrolet Volt. The contact stated that while his wife was driving 60 MPH, the message “Power Reduced” was displayed. The vehicle was taken to an independent mechanic who determined that the failure was due to the EGR valve. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 51,000.

While driving northbound on a freeway downhill, my vehicle suddenly lost power and displayed a "Shift to Park" message while still in motion. I was unable to accelerate, and the engine became unresponsive. The vehicle began coasting with no power, creating a dangerous situation. A semi-truck was in the lane next to me, and a car was behind me — I nearly got into an accident while trying to safely exit the roadway. This is the second report I’ve made regarding the same issue. The unexpected "Shift to Park" malfunction while driving is a serious safety concern that needs immediate attention.

Issue Summary: The Chevy Volt has experienced recurring electrical problems, including the "Shift to Park" message, loss of power, and dead 12V battery. The vehicle had to be towed to the dealership three times due to these issues. One incident involved a power loss while driving at 65 mph, which caused a near-miss with a semi-truck, posing a significant safety risk. Warranty Status: The additional warranty was purchased, but only one of the three incidents occurred while the vehicle was under warranty. Safety Concerns: The repeated electrical failures, especially while driving at high speeds, raise serious safety concerns

The contact owns a 2018 Chevrolet Volt. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the EVAP pipe was rubbing against the air conditioning hose connector. The dealer informed the contact that the vehicle was previously repaired under GM Campaign Number: N192273600; however, the failure persisted. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 84,800.

The issue started with a forward push while lowering my speed while coming to a stop. It then progressed to a trembling engine. Then it progressed to the car struggling to effectively switch from electric to gas and back. It then would only be usable on electric range and the engine would not start and would be greyed out. Now, it only works on engine mode, it uses fuel like a pick up truck, it loses power while driving due to trying to switch to electric mode and back, and it struggles to accelerate. It will do it while idle as well as while driving 45mph and up. It barely has any propulsion power and I have to turn my hazards on any time I am going to accelerate. If I brake hard the engine will shake violently and then shut off. I then have to switch gears from drive to park or neutral to park to drive to reengage the engine. Recently it has turned on all the accessories but the ev and the gas is greyed out and there is zero propulsion power. I replaced the 12v battery thinking it might have been dying and it still has the same issue. I read about the class action lawsuit for the BCEM and have made an appointment the dealership but when I told them what was wrong with it the said we need to wait for the diagnostics.

On 9/18/24 I was driving my Chevrolet 2018 Volt on a freeway, traveling at approximately 55 mph while starting to exit the freeway. In the middle of fast-moving traffic, on the freeway offramp and starting to decelerate, the car suddenly displayed a message saying "Propulsion Power is Reduced." A micro-second later, the displayed message changed to read "Action Required: Shift to Park" and in that moment I lost control of the car's powertrain. I continued to break, coming to a slow stop in the middle lane of a multi-lane offramp, with other cars speeding past and around me. I attempted to power the car down and reboot it, moving the gear shift into "Park" position as instructed, but nothing changed. The car remained totally inoperable. I was on a slight decline and noticed the car moving forward pulled by gravity, so I steered the car to the farthest right of the offramp/parallel street, where I put my hazard signals on and requested the car be towed to a mechanic. I was endangered because the car lost entire propulsion while in the middle of fast-moving freeway traffic, and fellow motorists were endangered as well. I have learned that this same behavior occurs routinely with 2nd generation Volts; that there is a special bulletin related to the car's BCEM *and* a related class-action lawsuit posed against GM/Chevrolet. I requested Chevrolet take preemptive action to repair the BCEM, as I am fearful the issue will repeat and cause additional danger to myself and fellow motorists, but Chevrolet says they cannot repair the part until it is diagnosed as defective... which will occur when/if the part fails again, and I'm already in danger.

The contact owns a 2018 Chevrolet. The contact stated that on several occasions while driving at various speeds, the vehicle lost motive power with the check engine warning light illuminated. The vehicle was steered to the side of the road and restarted each time, but the failure persisted. The vehicle was taken to the dealer where it was diagnosed that the EGR valve needed to be replaced and 40 unknown DTC codes had been retrieved. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 55,000.

My 2018 Chevy Volt displayed a warning message of "Propulsion Power is Reduced" on the dash when I started the car in a parking garage on Saturday, March 9th around 10am. The car would not drive normally and made a strange noise. I had to stop and start the car six or so times before it drove normally for me to get home. Had this happened at high speed, it could have caused an accident or worse. I contacted the local Rockville, MD Chevrolet dealership and they ran the diagnostic test on the BECM and HPCM2 systems and performed battery capacity reset. I do not believe this software reset will correct the technical issue. According to the dealership records, such a software reset was performed in 2021 by the previous owner before we purchased the car second hand in July, 2022. The dealer would not replace the BECM unit but there is supposedly a special coverage bulletin issued by General Motors. We need the unit replaced ASAP for safety.

While driving, an engine warning "Reduced propulsion Message" came on. Then it said " Engine Unavailable". The car would not go to gas engine. We panicked as we were 20mi from home and only had a few miles of electric left. I was able to drive to the nearest Chevrolet Dealership. It has been sitting there parked for 2 months. Uncharged. We are told that the problem is the EGR valve but no part is available anywhere. It is a known problem but GM has no parts available to fix. I am not getting any answer as to how long it may take to get the part. Meanwhile, I am without a vehicle. I only have approx 25,000 on the car. We have not been given a replacement car or been given any clear response from GM or the Dealership as to how long this may take to locate a part.

Chevy Volts from 2016 - 2019 all have a manufacturing defect which can prevent the driver from powering - the error message is "Shift to Park". GM released a Volt Service Bulletin in May 2021 but offered no assistance to replace the defective part. On [XXX] I was driving home on [XXX] headed [XXX] from Santa Cruz in fair weather in the afternoon. This highway can be dangerous with limited shoulders and poor visibility, making it an unsafe place to pull over. While traveling at about 55 mph, the car made an alert sound and illuminated the check engine light and presented a message "Shift to Park". I was running out of room on the shoulder to pull off safely so I had to make the quick decision to pull off to the left-hand shoulder. I followed the instructions on the display which said to shift into park, followed by shifting back into drive. During this time I had my foot on the brake, but after removing my foot from the break, the vehicle began to roll towards traffic, so I put my foot back on the break. I tried powering the car off/on multiple times and tried to get the car to go back into drive but was unsuccessful. Eventually, I put the car back into park, called a tow truck driver, and waited for over an hour to have my car safely towed off [XXX]. Prior to this, I had not experienced any of these or similar symptoms. An OBD code scan was done (screenshot attached). Once at the Chevy dealership, they confirmed that the car could, at that time, shift into park and were not able to reproduce the "Shift into Park" issue. However, they reported that the car was revving high and the transmission would not shift into the proper gear ratio. The dealership was not able to fully diagnose the problem and instead suggested to replace the entire transmission as assembly and then continue investigating. We reached out to the manufacturer, Chevrolet/GM, about the issue(s) and were ed case # [XXX] while they work with the dealership to investigate further. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

In August 2023, while driving on I-93 in Boston, car switched from Battery Mode to Engine Mode, and Driver Information Screen reported "Reduced Propulsion". Propulsion Battery charge and gasoline fuel levels were adequate such that this should not have happened. In this Reduced Propulsion state the environmental systems, i.e. Heat/Defrost/AC, become inoperative. A thunder storm overhead was pouring cold rainwater on the windshield and it became fogged inside from condensation. Because windshield Defrost was not functioning my passenger and I had no recourse but to frantically grab whatever we could to wipe away the condensation and keep some small amount of road visibility. This problem is intermittent. Car is available for inspection upon request. Reduced visibility in a moving vehicle is a safety hazard to the driver and all those in their vicinity. A dealer or service center has not been alerted. The vehicle has not been inspected for this problem. The intermittent problem of vehicle entering "Reduced Propulsion" Mode first occurred in July of 2023. I have an On Board Diagnostic (OBD) reader that always reports Diagnostic Trouble Code (DTC) P1E00 when the problem occurs.

the vehicle will lose power without warning on a regular basis. the vehicle will also accelerate unexpectedly when switching from battery to engine power at speeds under 50 mph. I have taken the vehicle to the dealer and have been informed there is nothing they can do for me, the vehicle does not have any faulty components.

Going 80 mph on the freeway with adaptive crusie control on, the car begins to jerk, and the rpm's shoot up and down. The adaptive cruise control disengages, the stabiltrack, abs, and engine light turned on and the car goes into limp mode. As I slow down, the speedometer keeps increasing up to 90. After, I inspected the driver wheel speed sensor and discovered that the sensor tip in the hub had been damaged. The anti-click washer had broken and began cutting the sensor until it failed.

WHENEVER I PUT MY VEHICLE IN PARK AND TURN IF OFF, THE SCREEN ON THE DASH WILL SAY "PLEASE SHIFT TO PARK." I WILL TURN ON MY VEHICLE AND THEN SHIFT IT TO PARK AGAIN AND TURN IT OFF. SOMETIMES IT WILL STOP NOTIFYING ME AFTER ONE TIME AND OTHER TIMES I WILL HAVE TO TURN IT OFF AND SHIFT IT TO PARK, EVEN THOUGH ITS IN PARK, SEVERAL TIMES. THE CAR WILL NOT TURN OFF AND I CANNOT LEAVE THE VEHICLE UNTIL IT STOPS NOTIFYING ME.

AFTER FULLY CHARGED MY CAR, I PULLED OUT OF THE PARKING GARAGE AND INTO AN AVAILABLE PARKING STALL AT WORK ON FRIDAY JANUARY 24TH 2020 AT APPROXIMATELY 1:50PM. I LET MY CAR CRUISE INTO THE STALL WHILE MY FOOT IS COVERING THE BRAKES. HALFWAY INTO THE PARKING STALL, THE CAR ACCELERATED ON ITS OWN. I APPLIED THE BRAKES BUT DID NOT HELP. IT STOPPED ONLY WHEN IT JUMPED THE FRONT CONCRETE STALL WITH 2 FRONT WHEELS AND HIT THE TREES THEN ROLLED BACK. I THEN IMMEDIATELY SHIFT THE GEAR TO PARK. THE DAY WAS SUNNY AND ROAD CONDITION WAS DRY. I WAS FORTUNATE THAT IT HIT THE TREES AND NOT OTHER CARS IF I WERE TO TAKE THIS OUT ON THE ROAD. THE ATTACHED PICTURES SHOWS TIRE MARKS AS I AM TRYING TO BRAKE AND THE TIRE WEARS.

CHEVROLET VOLT CANNOT BE DRIVEN IN DEEP SNOW. THE CAR WAS DRIVEN IN SNOW AT A SPEED OF ONE MILE PER HOUR COVERING 6 MILES IN 6 HOURS AFTER FIRST SNOW IN NYC NOV 15, 2018. THE PROTECTIVE UNDER CARRIAGE PANEL THAT COVERS THE ELECTRICAL AND TUBING BECOMES BRITTLE AND BREAKS AWAY WHEN IMPACTED.

I RAN INTO A VEHICLE IN FRONT OF ME DURING NORMAL TRAFFIC ON MY WAY HOME FROM WORK, TWO MONTHS TO THE DAY OF PICKING UP MY 2018 VOLT. THE VEHICLE AHEAD OF ME MAY HAVE STOPPED QUICKLY, BUT IT WAS NOT A STOP THE VOLT SHOULDN'T HAVE BEEN ABLE TO HANDLE. I WAS ON A STREET IN MY NEIGHBORHOOD I DRIVE EVERY DAY IN TRAFFIC. I HAD MENTIONED TO FRIENDS AND FAMILY THAT THE VOLT'S BRAKES JUST DID NOT FEEL ON PAR WITH THE REST OF THE CAR AND WOULD BE THE ONLY ASPECT OF THIS EV EXPERIENCE I FOUND LACKING. I HAVE THE DATED TEXT MESSAGES TO PROVE THIS. NOW I HAVE A VOLT AT THE BODY SHOP FOR THE 5TH WEEK (LACKING AN AC LINE FOR REASSEMBLY), AN OVER 55% INCREASE IN MY INSURANCE PREMIUMS (PER THE RENEWAL NOTICE I JUST RECEIVED) AND WHAT REALLY HASN'T BEEN A GOOD EXPERIENCE. WHILE I'M WAITING FOR THE RETURN OF MY VOLT I HAVE RECEIVED THE IMPORTANT SAFETY RECALL INDICATING THE BRAKING PERFORMANCE MAY BE REDUCED. IF THE CAR HAD BEEN ABLE TO STOP TWO FEET SHORTER I'D HAVE AN UNDAMAGED THREE MONTH OLD VOLT AND MY INSURANCE STANDINGS UNTARNISHED. THAT TWO FEET ENDED UP COSTING OVER $17,500 TO THE CAR. TURNS OUT VOLTS ARE ALSO EXPENSIVE TO REPAIR. I'M A 55 YEAR OLD MALE, NO WILD KID. STILL STUNS ME THAT IN 2018 GM CAN'T GET BRAKES RIGHT...THE MOST IMPORTANT OF SAFETY SYSTEMS.