2021 CHRYSLER Voyager Problems

Complaints Reported

Complaints by Component

STEERING

2 complaints

I was driving in the highway and my steering became so stiff that I could barely turn the wheel.It wasn’t just stiff, It was almost impossible to make a turn unless I use all my strength and turn the wheel with both of my hands. . It made me pull over the car and get it towed to the dealership. This was very dangerous because I couldn’t react to oncoming traffic or make regular turns on the street safely. There is no way people should be driving these cars if the power steering can go down with no warning. I could’ve hit somebody and caused a major accident on the highway. This needs to be recalled.

Nov 19, 2025

The steering wheel sticks when exiting a turn, this can be reproduced on every turn. There is a risk of overcompensating steering if you do not anticipate the steering wheel sticking. There is also a vague spot in the steering when driving in a straight line, the vehicle will drift to one side and when you correct it will drift to the other side. Wheel alignment was checked and tires are in good condition. The dealer inspected the vehicle and confirmed the steering problem, the steering components were replaced by the dealer and this corrected the steering problem. The were no warning lights, no messages and no sounds emanating from the steering. The vehicle was not in any accidents - to our knowledge.

Sep 09, 2025

POWER TRAIN

2 complaints

I purchased a 2021 Chrysler Voyager in August 2024 from Apple Autos in Shakopee MN. When we purchased the car, there has always been a rough idle and were assured that this was due to the automatic start/engine. Around July 2025, I began experiencing engine issues that have persisted for over two months. Initial issues were a significant rough idle and car dying. We brought the car in and repaired both batteries and replaced all the spark plugs. The issues have persisted. Symptoms include overheating, coolant loss, and misfires on cylinder 3. Diagnostics suggest a head gasket failure. This issue poses a safety risk, especially if the engine fails while driving. I’ve attempted repairs, but the problem remains unresolved. I’m concerned this may be a premature failure affecting other vehicles of the same model and engine type. There is no official recall for head gasket failure on the 2021 Chrysler Voyager, but there are numerous owner reports and forum discussions suggesting that early engine failure and head gasket issues are a concern—especially for vehicles that were former rentals or have the 3.6L Pentastar V6 engine, which is shared with the Chrysler Pacifica. Several Voyager owners have reported head gasket failures around 50,000–70,000 miles. These issues often appear shortly after warranty expiration, leading to costly repairs. I am requesting that NHTSA investigate this issue and consider whether a recall or manufacturer intervention is warranted.

Sep 08, 2025

I was driving on a freeway. My car had no warning lights. Suddenly the dash lit up like a Christmas tree and the car lost all power. The engine was running, but the gas pedal was unresponsive. The transmission went to neutral. I was forced to coast to the side of the road. Luckily there was somewhere to go. Someone was trying to merge as I was slowing down. It was quite scary. Once the car stopped, it put it self into park and I was stuck. After about twenty minutes, the warning lights turned off and the car drove normally. This happened 3 more time. I finally parked the car. I took it to a mechanic, but said he couldn't work on it because Chrysler hadn't released the technical information for the diagnostic system. I tried cleaning the connections to the computer and the car ran great. The next day I tried driving to work and the car died again. I was going up hill and car quickly came to a stop in front someones driveway. I tried putting the car in neutral, so that I could drift backwards out of the way. The car kept putting itself pack into park. I've had many cars break down on me over there years, but I was always able to get out of harms way by drifting to a safe location or pushing the car off the road. Being stuck in park is an unacceptable safety hazard. If the car had ever broke down on a busy freeway, I would be stopped in the middle of lane, waiting for someone to smash into me from behind.

Jul 23, 2024

ELECTRICAL SYSTEM

2 complaints

After going through rapid acceleration, van will experience electrical issue which does not allow for acceleration and triggers auto stop to fail. The electrical issue prevents the van from accelerating while in motion on a highway. This issue has persisted every year, despite replacing both the main and auxiliary batteries. Both batteries have failed within a year and recently after a week of being replaced.

Jul 19, 2025

The contact owns a 2021 Chrysler Voyager. The contact stated that after stopping at a stop sign, the contact depressed the accelerator pedal and the vehicle inadvertently shifted into park and shut-off. The contact was able to restart the vehicle. The automatic start stop warning light was illuminated. The dealer was made aware of the failure and had scheduled an upcoming appointment for diagnosis. The vehicle was not repaired. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Campaign Number: 19V348000 (Electrical System). The failure mileage was 241.

Aug 17, 2021

UNKNOWN OR OTHER

2 complaints

My rear camera is not working properly. This started around [XXX]. Also apparently my auto stop is no longer working this is the second time this has happened to me last year end of 8/24 - 9/24 I had it fixed at a dodge dealer in New Jersey and now it has happened again. I don’t understand how in less then a year I’m dealing with the same problem I really think I was sold a lemon. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Jul 17, 2025

In the 2 years that I owned the van I have walked away from the car after a journey and accidentally left the van running 3 times and my mechanic has done it once. 2 of those times it was left running all night. Once it ran out of gas. It seems to happen when I am distracted. The safety issue is that the van has no warning system when this happens and there is a lot of carbon monoxide released into the air. It could be lethal in an enclosed area. Also, note that it is a push button start and I have the key fob with me when this happens, so the fob is far away from the van and it is still running.

Apr 09, 2024

STEERING,UNKNOWN OR OTHER

1 complaint

When we go to turn a certain way the wheel sticks while In drive, mechanic says it could be steering tie rods or rack and pinions

Oct 13, 2025

VEHICLE SPEED CONTROL,ENGINE

1 complaint

The contact owns a 2021 Chrysler Voyager. The contact stated while driving approximately 30 MPH, the vehicle unintendedly accelerated while depressing the brake pedal. The contact stated that the electronic throttle control warning light was illuminated. The contact depressed the brake pedal and was able to slow the vehicle. Additionally, the contact stated that the vehicle failed to respond as needed while depressing the accelerator pedal. The contact stated that the electronic throttle control warning light was illuminated. The contact stated that while depressing the accelerator pedal the vehicle failed to respond. The contact stated that the engine was not revving while depressing the accelerator pedal. The contact stated that the failure was intermittent. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 47,000.

Mar 31, 2025

ENGINE

1 complaint

Blown head gasket at 116k miles and it’s a known issue for these vehicles (Chrysler/Jeep). They are faulty and nothing is being done

Dec 04, 2024

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,VISIBILITY/WIPER

1 complaint

My back up camera has stopped working for months. There is open recalls for the same exact vehicles but not for my specific VIN. I am trying to get this fixed as soon as possible.

Nov 14, 2024

ELECTRICAL SYSTEM,SEATS

1 complaint

mid row seat headrest won’t go back to fixed position after being stowed. potentially neck injury could and can occur if in any sort of accident. wired carplay issue, won’t work for apple. cannot use carplay with any iphone.

Jul 11, 2024

SEATS

1 complaint

Our second row seat on the passenger side has a head rest that will not fold upright and lock into place. The seat itself is useless due to the headrest not folding up correctly and is a safety hazard for anyone to sit in it. I bought this vehicle for the purpose of having all available seats to be used for our family and now we have one seat that cannot be used. No matter how many times we tried to push it up or folding the seat all the way down and then back up it still does not lock into place on the headrest. We have did research and many people have had the same issue and have not been able to get it fixed even after taking it to a repair service or dealer. This needs to be a serious recall and should be fixed if so many others have had the same issues.

Mar 04, 2024

⭐

4.2/5.0

85 reviews

Frequently Asked Questions

How many problems does the 2021 CHRYSLER Voyager have?

The 2021 CHRYSLER Voyager currently has 14 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2021 CHRYSLER Voyager?

The most common problems reported for the 2021 CHRYSLER Voyager are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2021 CHRYSLER Voyager problem data come from?

All problem and complaint data for the 2021 CHRYSLER Voyager comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.