2007 DODGE Grand Caravan Problems & Complaints
Real owner complaints and problems reported to the National Highway Traffic Safety Administration (NHTSA). View common issues by component.
182
Complaints Reported
Complaints by Component
FUEL/PROPULSION SYSTEM
20 complaints
AFTER EACH AND EVERY VEHICLE FUELING, THE VEHICLE STALLS SEVERAL TIMES CAUSING LOSS OF STEERING AND BRAKES. THIS IS DANGEROUS AND UNSAFE AS THIS SCENARIO HAPPENED TO ME AT AN INTERSECTION AND AT A TURN NEARLY CAUSING ME TO HAVE AN ACCIDENT. *TR
May 08, 2020
AFTER ALMOST EVERY FILL UP VEHICLE STALLS WHEN GOING DOWN ROAD. AFTER RESEARCHING THE PROBLEM I FOUND THE VAPOR/LIQUID SEPARATOR VALVE IS DEFECTIVE. EVIDENTLY THIS IS A COMMON PROBLEM AND A SAFETY ISSUE IN MY OPINION. TO BE DRIVING DOWN THE ROAD AND YOUR VEHICLES SHUT DOWN IS DANGEROUS. WHY DOES THE MANUFACTURER NOT HAVE A RECALL ON THIS PROBLEM.
Nov 17, 2019
AFTER FILLING THE FUEL TANK THE VEHICLE STALLS, AND SPUTTERS WHEN PULLING INTO TRAFFIC, AND DRIVING DOWN THE ROAD FOR UP TO 1 MINUTE
Nov 27, 2018
CAR STALLS AND SOMETIMES DIES AFTER REFUELING. THIS ALWAYS HAPPENS AFTER PULLING ONTO ROAD INTO TRAFFIC. SO FAR I HAVE AVOIDED BEING HIT BY ANOTHER CAR! THIS HAS BEEN HAPPENING FOR A LONG TIME. DEALER SAYS REPLACE FUEL TANK,POOR DESIGN.
Jun 22, 2017
STALLING AFTER REFUELING WHEN I FILL UP MY GAS TANK, ALMOST IMMEDIATELY AFTERWARD PULLING OUT OF THE GAS STATION MY VAN SPUTTERS, MISSES, HESITATES, CALL IT WHAT YOU WILL. THE PAST COUPLE OF TIMES THE ENGINE HAS ACTUALLY STALLED AS WELL.
Jun 01, 2016
+ 15 more complaints for this component
POWER TRAIN
15 complaints
MY STEPDAUGHTER WAS DRIVING MY VAN AFTER WE WERE RETURNING FROM A TRIP TO CALIFORNIA. WE GOT TO HER HOUSE TO DROP HER OFF WHERE SHE PUT THE VAN IN PARK . I THEN WALKED (BEHIND) FROM THE PASSENGER SIDE TO THE DRIVERS SIDE WHILE SHE WENT TO HER MAIL BOX TO GET HER MAIL. I OPENED THE DRIVER SIDE DOOR, THAT'S WHEN THE VAN STARTED ROLLING BACKWARDS DOWN HER DRIVEWAY. I COULDN'T SEE HER SO I SCREAMED HER NAME SO IT DIDN'T RUN OVER HER, SHE WAS DIRECTLY BEHIND THE VAN LOOKING DOWN AT HER MAIL. SHE GOT OUT OF THE WAY IN TIME TO SEE THAT THE VAN DOOR HAD CAUGHT ME, WAS ABLE TO REACH ME, LUCKILY, TO GRAB AND YANK ME FROM BEHIND IT. THEN WE WATCHED AS IT ROLLED DOWN HER DRIVEWAY INTO THE STREET. LUCKILY WHEN IT HIT THE BOTTOM OF HER DRIVEWAY THE WHEELS TURNED OR IT WOULD HAVE GONE DOWN HER STREET AND CROSSED A SIDE ROAD. THE DOOR CAUGHT A LARGE RECYCLE BIN CAUSING FRONT END DAMAGE AND BENT THE DOOR BACKWARDS ENDING UP WITH THE REAR END HITTING A LARGE SNOW BANK WHERE IT CAME TO REST. THIS WAS A FRIGHTENING INCIDENT, ONE OR BOTH OF US COULD HAVE BEEN KILLED! EVEN WORSE OTHERS COULD HAVE BEEN IF THE VAN HAD GONE INTO THE STREET(S). THE VAN WENT INTO NEUTRAL, I PHYSICALLY SAW IT AND HAD TO SHIFT IT INTO DRIVE TO GET IT OFF THE CURB. SINCE THEN, NUMEROUS TIMES, WHEN I HAVE BEEN BACKING UP OR JUST STARTING TO DRIVE, IT WILL POP INTO NEUTRAL. EACH TIME I HAVE TO PUT IT BACK INTO REVERSE OR DRIVE. THIS IS DANGEROUS!!! WHAT IF IT HAPPENS WHEN I AM DRIVING OUT OF MY DRIVEWAY OR PULLING OUT ONTO A STREET ETC? MY HUSBAND HEARD A STORY TODAY THAT OTHER CHRYSLER VEHICLES ARE HAVING THE VERY SAME ISSUE. I THINK THIS IS AN ONGOING PROBLEM THAT THEY HAVE HAD FOR MANY MANY . IT NEEDS TO CHANGE. WHO ELSE CAN I COMPLAIN TO? I INFORMED CHRYSLER/DODGE WHEN IT HAPPENED AND HEARD NOTHING BACK.
Feb 09, 2016
MY 2007 DODGE GRAND CARAVAN WAS PARKED IN THE DRIVEWAY AND MY 4 YR OLD WAS ABLE TO SHIFT THE VAN OUT OF PARK INTO NEUTRAL WITHOUT DEPRESSING THE BRAKE OR STARTING THE VEHICLE. THE VAN COASTED DOWN THE DRIVEWAY, ACROSS THE STREET AND CAME TO REST IN THE NEIGHBOR'S YARD ALL THE WHILE WITH MY 4 YR OLD IN THE DRIVER'S SEAT. I WOULD ESTIMATE THE VEHICLE WAS TRAVELING UP TO 10MPH DOWN THE SLOPED DRIVEWAY. NO INJURY OR DAMAGE LUCKILY OCCURRED. SUBSEQUENTLY, THE DODGE DEALERSHIP STATES THE SHIFT INTERLOCK SOLENOID FAILED. THE DEALERSHIP WILL NOT COVER UNDER WARRANTY. I BELIEVE THIS SHOULD BE CONSIDERED A RECALL ISSUE SINCE THIS IS A MAJOR SAFETY ISSUE AND HAS BEEN THE PREVIOUS SUBJECT OF NHTSA INTERVENTION WITH THE AUTOMAKERS. *TR
Mar 26, 2012
THIS ISSUE HAS OCCURRED AROUND 20 TIMES SINCE PURCHASE OF THE VEHICLE. WHILE DRIVING THE VAN AND STOPPING IN TRAFFIC (TRANSMISSION IN DRIVE), WHEN PUSHING THE GAS PEDAL (FOOT OFF THE BRAKE) THE RPM GAUGE WILL RESPOND BUT THE VAN WILL NOT MOVE. THE VAN BEHAVES LIKE THE TRANSMISSION IS IN PARK DESPITE THE TRANSMISSION BEING IN DRIVE. IN ORDER FOR THE VAN TO MOVE AGAIN YOU MUST PUT THE VAN IN PARK AND THEN BACK TO DRIVE. AT THIS POINT THE TRANSMISSION WORKS AS IT SHOULD. AT LEAST TWICE I HAVE HAD TO TURN THE VAN OFF AND BACK ON BEFORE THE TRANSMISSION WOULD WORK CORRECTLY. HAVE TAKEN TO DEALER BUT THEY COULD NOT REPLICATE AND THERE WERE NO CODES TO PULL. I FEEL THIS IS A SERIOUS SAFETY ISSUE AS IT COULD LEAD TO AN ACCIDENT. *TR
Jan 24, 2012
PARKED FACING DOWNHILL WITH VEHICLE IN PARK AND PARKING BRAKE ON. CAR WOULD NOT CHANGE GEAR USING COLUMN LEVER. GOT OUT OF VEHICLE TO CHECK UNDER HOOD FOR A PROBLEM. NOTICE CABLE DISCONNECTED FROM LEVER ON TRANSMISSION. WHEN I WAS ABOUT TO REACH IN TO GET THE CABLE, THE VEHICLE POPPED OUT OF GEAR AND ROLLED DOWN HILL, THE HOOD SLAMMED MY ARM TRAPPING IT AS THE VEHICLE ROLLED DOWNHILL. I BECAME TRAPPED BETWEEN ANOTHER CAR AS IT PUSHED ME 20 FEET DOWNHILL. ANOTHER PASSER BY WAS ABLE TO GET IN THE VEHICLE AND PUT THE BRAKE WHILE I PRIED MY ARM OUT CAUSING NERVE DAMAGE. THE HOOD WOULD NOT RELEASE WHILE MY ARM WAS STUCK. *TR
Apr 29, 2011
2007 DODGE GRAND CARAVAN HAD BEEN PARKED FOR 6 DAYS WHILE WE WERE AWAY ON VACATION. RETURNED TO AIRPORT AND DROVE VEHICLE HOME (30 MILES). NEXT MORNING DROVE VEHICLE INTO TOWN (15 MILES) WITH NO PROBLEMS. PARKED FOR 1 HOUR THEN WENT TO RETURN HOME. WITHIN A FEW MILES THE VEHICLE MOVED ITSELF INTO A NEUTRAL STATE (DISPLAY SHOWED "D" STILL) WHILE MOVING DOWN THE ROAD. THIS WAS IMMEDIATELY MADE AWARE AS THE VEHICLE BEGAN TO SLOW AND THE ENGINE QUICKLY REVVED HIGH. WAS BARELY ABLE TO COAST SAFELY INTO A PARKING AREA. TURNED VEHICLE OFF FOR 5 MINUTES, THEN RESTARTED AND IT DROVE THE REST OF THE WAY HOME. ISSUE IS THAT THE VEHICLE MOVED ITSELF INTO NEUTRAL WITHOUT REASON AND ALSO DID NOT UPDATE DISPLAY. WE LIVE IN MICHIGAN AND TEMPERATURE HAS BEEN 35 DEGREES OR LESS RECENTLY. *TR
Apr 07, 2011
+ 10 more complaints for this component
ENGINE,FUEL/PROPULSION SYSTEM
11 complaints
WITHIN MINUTES OF FUELING, THE ENGINE WILL STALL CAUSING A LOSS OF STEERING AND BRAKES.
Mar 12, 2017
THE LAST FEW TIMES I HAVE COMPLETELY FILLED UP MY GAS TANK - THE VEHICLE HAS STALLED. I HAVE HAD TO TRIED TO STOP AND RESTART THE IGNITION/ENGINE A NUMBER OF TIMES FOR THE VEHICLE TO RUN. THIS IS HAPPENING WITH FULL GAS FULL-UP AND HAPPENED TO ME AGAIN LAST NIGHT. I HAVE SEEN THIS AS BEING A COMMON PROBLEM FOR CHRYSLER/DODGE MINIVANS IN A FEW ON-LINE FORUMS. SOME REPORTS HAVE THE VEHICLES STALLING ON HIGHWAYS AND/OR WHEN DRIVING. MY VEHICLE IS A 2007 DODGE GRAND CARAVAN SXT. *TR
Apr 06, 2015
THE ENGINE STALLED TWICE WITHIN 5 MINUTES OF REFUELING. THE VEHICLE WAS FILLED WITH UNLEADED 87 OCTANE GAS TO FULL. THE GAS PUMP AUTO STOPPED WHEN FULL, AND THE TANK WAS NOT TOPPED OFF. THE FIRST STALL HAPPENED WHILE THE VEHICLE WAS IDLING AT A STOP SIGN APPROXIMATELY 1 MINUTE AFTER FUELING. THE ENGINE RESTARTED, BUT STALLED AGAIN APPROXIMATELY 2 MINUTES LATER. THE SECOND STALL OCCURRED WHILE THE VEHICLE WAS IN MOTION AT APPROXIMATELY 15-20 MPH AND TURNING LEFT. THE STALL LEFT THE VEHICLE WITHOUT POWER STEERING, AND THE VEHICLE COASTED INTO A DRIVEWAY. THERE WAS NO ACCIDENT BECAUSE OF LIGHT TRAFFIC. UNDER DIFFERENT CIRCUMSTANCES OR TRAFFIC PATTERNS, A STALLED ENGINE LEAVING A MOVING VEHICLE POWERLESS LIKELY WOULD CAUSE AN ACCIDENT RESULTING IN POSSIBLE INJURY OR DEATH. THIS SAME PROBLEM HAS OCCURRED APPROXIMATELY 5-6 TIMES IN THE LAST 2 YEARS, HOWEVER I CAN NOT BE SPECIFIC ON DATES. IT WAS ONLY WHEN MY WIFE AND I WERE TOGETHER THIS LAST TIME THAT WE BOTH COMMENTED ON THE PROBLEM, AND FOUND THAT IT HAS HAPPENED TO EACH OF US SEVERAL TIMES. I BELIEVE ANY MANUFACTURER DEFECT WHICH CAUSES A MOVING VEHICLE TO LOSE POWER AND BECOME UNCONTROLLABLE WHILE IN MOTION IS AN EXTREMELY SERIOUS AND POTENTIALLY DEADLY PROBLEM. *TR
Mar 23, 2015
THE VEHICLE STALLS AFTER RE-FUELING. WE RE-FUEL AT DIFFERENT GAS STATIONS (BRANDS) AND THE ISSUE REMAINS. EVERY TIME WE FILL THE TANK AND PULL OUT OF THE GAS STATION INTO TRAFFIC, THE ENGINE SPUTTERS AFTER DRIVING APPROXIMATELY TWO BLOCKS, AS IF IT IS NOT RECEIVING ENOUGH FUEL. THE ENGINE THEN STALLS. THE ENGINE CAN BE RESTARTED AND WILL NOT SPUTTER OR STALL UNTIL THE NEXT TIME WE RE-FUEL IT. WE ENCOUNTER THIS ISSUE WEEKLY, AFTER EVERY FILL UP. IT IS A POTENTIALLY DANGEROUS ISSUE BECAUSE THE VEHICLE STALLS IN TRAFFIC AND COULD CAUSE A TRAFFIC ACCIDENT. *TR
Mar 21, 2015
TL*THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT AFTER REFUELING, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.
Mar 09, 2015
+ 6 more complaints for this component
ENGINE AND ENGINE COOLING
10 complaints
DEAR SIR/MADAM: MY 2007 DODGE MINIVAN MANUFACTURED BY CHRYSLER HAS A DEFECTIVE ENGINE. THE 3.8L ENGINE BURNS OIL AND OIL CONSUMPTION TESTS DONE PROVED THE SAME. I WAS MADE AWARE OF THIS ISSUE BY MECHANICS OUTSIDE OF DEALERSHIP SERVICE WHICH WHEN NOTIFIED BACK, RELUCTANTLY ACCEPTED THE ISSUE AND WENT ON TO STATE THAT I HAD TO PAY TO FIX THE PROBLEM RELATED TO WORN OUT PISTON RINGS. REPAIRS OF THIS NATURE ARE EXPENSIVE AND ON BRIEF RESEARCH ON INTERNET, OTHER CUSTOMERS HAVE EXPERIENCES THE SAME PROBLEMS. WHEN VEHICLE WAS UNDER WARRANTY, I ENCOUNTERED MANY ENGINE RELATED SYMPTOMS LIKE SLUGGISH PERFORMANCE, ENGINE WHINING OR HISSING NOISE AND SUCH. IT'S MY BELIEF THAT CHRYSLER SERVICE FAILED TO DO NECESSARY TESTS TO DETECT THIS ISSUE. *TR
May 06, 2012
MY 2007 GRAND CARAVAN IS BURNING OIL. CURRENTLY GOING THROUGH OIL CONSUMPTION TEST WITH DEALER. CAR IS BURNING APPROX. 1 QT. OF OIL EVERY 1000 MILES. CHRYSLER SAID IT IS WITHIN ACCEPTABLE LEVELS OF USAGE.CAR ONLY HAS 44,000 MILES.NOTHING HAS BEEN DONE TO CORRECT THIS OBVIOUS DEFECT,EVEN THOUGH I BOUGHT AN EXTENDED WARRANTY FROM CHRYSLER. *TR
Jun 24, 2011
REAR EVAPORATOR LEAK -AIR CONDITIONING SYSTEM DOES NOT WORK- EVAPORATOR AND ALUMINUM HOSES ARE 6" FROM REAR TIRE - THE EVAPORATOR WILL BE DAMAGED AND/OR CORRODE/OXIDIZE AT SOME POINT AND LEAK - IT WILL COST BETWEEN $800 - $1500 TO REPAIR FOR AN OBVIOUS DESIGN PROBLEM - IF IT HASN'T LEAKED YET IT WILL FROM THE ON-LINE COMPLAINTS THAT I'VE SEEN. *TR
May 16, 2011
EGR VALVE PROBLEM CODE P0404 ON DODGE 2007 GRAND CARAVAN. *TR
Feb 05, 2011
TL*THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE CHECK THE ENGINE LIGHT CAME ON WHENEVER THE VEHICLE WAS DRIVEN FOR MORE THAN ONE OR TWO HOURS. THE VEHICLE ALSO BEGAN TO LOSE POWER. THE CONTACT TOOK THE VEHICLE A LOCAL MECHANIC WHO STATED THAT THE CODE IDENTIFIED THE FAILURE AS EMISSIONS. THE CONTACT STATED THAT THE EMISSIONS WAS RELATED TO THE ERG VALVE FAILING WHICH CAUSED OIL TO ENTER INTO THE ENGINE. THE FAILURE MILEAGE WAS 78000 AND THE CURRENT MILEAGE WAS 85000.
Dec 23, 2010
+ 5 more complaints for this component
AIR BAGS
9 complaints
TL* THE CONTACT OWNS A 2007 DODGE GRAN CARAVAN. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR HAD BEEN ILLUMINATING ON AND OFF FOR APPROXIMATELY ONE MONTH. THE VEHICLE WAS TAKEN TO MACDONALD MOTORS AUTO GROUP DEALER IN BRIDGTON, ME THAT DIAGNOSED THE VEHICLE AS HAVING OCCUPANT RESTRAIN MODULE FAILURE AND NEEDED REPLACEMENT. THE VEHICLE WAS REPAIRED BUT THE WARNING INDICATOR KEPT ILLUMINATING. THE VEHICLE WAS DIAGNOSED AGAIN BY MACDONALD MOTORS AUTO GROUP DEALER AND WAS DIAGNOSED AS A SEAT SENSOR FAILURE. THE CONTACT PURCHASED A USED SEAT FROM A SALVAGE YARD. THE VEHICLE WAS REPAIRED, BUT THE WARNING INDICATOR WAS STILL ILLUMINATING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 113,000.
Sep 05, 2017
MY WIFE IS HANDICAPPED. I OWN A LOWERED FLOOR MINIVAN WITH A RAMP FOR WHEELCHAIR ACCESS. VANTAGE MOBILITY INTERNATIONAL ("VMI"), 5202 SOUTH 28TH PLACE, PHOENIX, AZ 85040, (602) 243-2700 DID THE CONVERSION OF MY 2007 DODGE GRAND CARAVAN TO MAKE IT HANDICAPPED ACCESSIBLE ("RAMP VAN"). DODGE/CHRYSLER ("DODGE") WORKS WITH VMI AND A DODGE DEALER IN TEMPE ARIZONA TO SELL RAMP VANS NATIONWIDE THROUGH A DEALER NETWORK. RAMP VANS ARE SOLD THROUGH LOCAL DEALERS WHO PROVIDE BOTH WARRANTY AND NON WARRANTY SERVICE FOR THE CONVERSION ELEMENTS OF THE RAMP VANS. LOCAL DODGE DEALERS PROVIDE NON-CONVERSION WARRANTY AND NON-WARRANTY SERVICE. IT IS NOT UNUSUAL FOR EACH TO POINT THE FINGER AT THE OTHER CONCERNING ELECTRICAL AND MECHANICAL PROBLEMS. THE DRIVER'S SIDE FRONT AIR BAG DOES NOT WORK PROPERLY. IT ONLY OPERATES INTERMITENTLY. IT HAS BEEN TAKEN TO BOTH VISION DODGE (920 PANORAMA TRAIL SOUTH, ROCHESTER, NY 14625, (585) 385-5700, AND AUTOCRAFTING 72 HINCHEY ROAD, ROCHESTER, NY 14624 ON SEVERAL OCCASIONS FOR REPAIRS TO THE AIRBAG SYSTEM. AUTOCRAFTING REPORTED THAT VMI WAS INVOLVED IN TROUBLESHOOTING THE PROBLEM. BETWEEN VISION DODGE AND AUTOCRAFTING THERE HAVE BEEN 3 OR 4 ATTEMPTS TO FIX THE AIRBAG PROBLEM TO NO AVAIL. VISION DODGE CHARGED ME SUBSTANTIAL COSTS FOR REPAIRS THAT DID NOT FIX THE PROBLEM. NEITHER DODGE NOR VMI HAS BEEN ABLE TO FIX THE PROBLEM. THE AIR BAG FAILURE AND THE INABILITY OF DODGE AND VMI TO FIX IT INDICATES A MAJOR DESIGN FAILURE IN AN ESSENTIAL AND LEGALLY REQUIRED SAFETY SYSTEM. THE AIRBAG SYSTEM GOES ON AND OFF WHILE BEING DRIVEN ON CITY STREETS AND HIGHWAYS AS REPORTED BY THE VEHICLE'S WARNING LIGHTS. WHOEVER IS DRIVING THE VEHICLE IS AT SERIOUS RISK OF DEATH OR INJURY SHOULD THE VAN BE INVOLVED IN AN ACCIDENT WITH THE AIRBAG NOT WORKING. OCCURRED 12/2015 AND FROM OCTOBER 2016 TO DATE.
May 13, 2017
SEAT BELT LIGHT STAYS ON EVEN THOUGH THERE HAVE BEEN NO ACCIDENTS OR BAG DEPLOYMENTS.
Jan 07, 2017
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE DRIVER AND PASSENGER AIR BAG INDICATORS FLASHED ON AND OFF. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000.
Sep 12, 2016
4/17/2016 WE HAD AN ACCIDENT WHICH TOTALED OUR VAN. THE FRONT WAS DAMAGED AND THE VAN WAS TOTALED HOWEVER THE AIR BAGS DID NOT DEPLOY EVEN THE WINDSHIELD WAS DAMAGED
Apr 13, 2016
+ 4 more complaints for this component
ELECTRICAL SYSTEM
8 complaints
WHEN TURNING ON RIGHT TURN SIGNAL IT FLASHES AND SHUTS OFF WHILE THE SWITCH IS STILL ON. WHEN I SIGNAL LEFT IT DOESN'T WORK AT TIMES, ALL THIS HAPPENS WHILE THE VEHICLE IN IN MOTION ON THE ROAD. I TRIED CONTACTING DODGE AND THEY WERE NO HELP. THIS IS A HUGE SAFETY ISSUE AND COULD LEAD ME TO GET PULLED OVER OR IN AN ACCIDENT
Jul 04, 2018
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHILE DRIVING 60 MPH, THE VEHICLE STALLED. THE CONTACT STATED THAT THE FUSE BOX LOCATED UNDER THE HOOD IN THE ENGINE COMPARTMENT BECAME OVERHEATED. THE FUSES WERE EXTREMELY HOT AND SMOKING. THE VEHICLE WAS TOWED BACK TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 189,863.
Jan 05, 2018
DURING PARK REAR PASSENGER DOOR WOULD NOT OPEN FROM THE INSIDE MANUALLY AND ELECTRONICALLY, SOMEONE FROM THE OUTSIDE HAS TO OPEN THE DOOR. THE UNLOCK MECHANISM IS UP BUT THE DOOR BUTTON FROM THE INSIDE WOULD NOT PUSH DOWN, THEREFORE NOT ALLOWING THE VAN DOOR TO OPEN. THIS IS BIG SAFETY PROBLEM, NO ONE CAN GET OUT MANUALLY AND ELECTRONICALLY FROM THE INSIDE. TOOK IT TO DODGE AND THEY CLAIM IT'S THE WIRE, BUT IT'S NOT BECAUSE THE WIRE IN GREAT CONDITION, BECAUSE IT'S BEEN REPLACE AND STILL HAVING THE SAME PROBLEM. IT'S NOT MOTOR BECAUSE ONCE IN A BLUE MOON IT WOULD OPEN PARTIALLY, BUT IT WOULD CLOSED AUTOMATICALLY IMMEDIATELY. I HAVE FILE NUMEROUS COMPLAINTS TO DODGE BUT NOTHING WAS DONE. I BELIEVE IT'S ELECTRONIC PROBLEM, WHICH HAS TO DO WITH ECM (ELECTRONIC CONTROL MODULAR). PLEASE CONTACT DODGE GRAND CARAVAN TO DILIGENTLY CHECK INTO THIS SAFETY ISSUE. THANK YOU. *TR
Dec 16, 2015
TL*THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 30 MPH, THE VEHICLE STALLED. THE CONTACT STATED THAT THE FAILURE WAS PROGRESSING BUT THE VEHICLE WAS ABLE TO BE RESTARTED EACH TIME THE FAILURE RECURRED. THE VEHICLE WAS NOT INSPECTED OR DIAGNOSED. THE CONTACT WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 11V139000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 55,433.
Mar 09, 2015
VEHICLE SHUT OFF WHILE DRIVING ON INTERSTATE AT 48MPH AND INCREASING. FIRST ALL DIALS DROPPED TO 0, BRAKES WOULD NOT WORK, WHEN PRESSING ACCELERATOR ENGINE WOULD REV UP BUT NO POWER - THEN THIS STOPPED ALSO. TURNED KEY TO OFF POSITION AND WAITED A FEW MINUTES, THEN TURNED CAR BACK ON AND ALL SEEMED WELL. THIS WAS VERY SCARY WITH CARS & TRUCKS WHIPPING BY AT 50 PLUS MPH! *TR
Oct 02, 2014
+ 3 more complaints for this component
STRUCTURE
7 complaints
IF VARIOUS OTHER DESIGN FLAWS WITH OTHER VEHICLE PARTS HAVE BEEN DEEMED WORTHY OF RECALL TO BE REDESIGNED BECAUSE THEY HAVE FAILED TO DO THAT FOR WHICH THEY WERE DESIGNED...THEN I FEEL LIKE DODGE AND CHRYSLER SHOULD RECALL MILLIONS OF MINI VANS THEY HAVE PRODUCED IN EARLY 2000'S THAT HAVE TOTALLY RUSTED OUT LOWER PORTION OF SIDE SLIDING DOORS...TOTAL DESIGN FLAW!!!!! A DESIGN FLAW IS A DESIGN FLAW...MANUFACTURES FAULT. THANKS FOR LISTENING..[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT
Jun 29, 2019
THERE HAVE BEEN MANY MECHANICAL ISSUES (ELECTRICAL?) INCLUDING SLIDING DOORS THAT DO NOT WORK ANYMORE (THEY MUST BE CLOSED MANUALLY). BUT THE MAIN PROBLEM I WANT TO REPORT IS RUST. UNDER THE WHEELWELLS, UNDER THE SLIDING DOORS, ON THE BOTTOM OF THE TRUNK HATCH DOORS... IT'S RUSTING APART. FOR A 2007 VEHICLE THIS IS QUITE EXCESSIVE. I'VE ALSO NOTICED THAT OTHER DODGE GRAND CARAVANS OF THE SAME MARINE BLUE GREEN COLOR HAVE THE SAME EXACT PROBLEM. HAS THIS BEEN INVESTIGATED? RUSTING APART... AND IT'S BEEN HAPPENING FOR A COUPLE OF YEARS NOW. YOU WOULD THINK A VEHICLE WOULDN'T START TO HAVE NOTICEABLE AND PERVASIVE RUST IN 7 OR 8 YEARS TO THE POINT WHERE YOU ARE EMBARRASSED TO DRIVE IT.
Nov 23, 2016
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE ENTERING THE VEHICLE, A CHILD BECAME CAUGHT IN THE PATH OF THE CLOSING AUTOMATIC SLIDING DOOR. THE CHILD BECAME PINNED TO THE FRAME AND SUSTAINED MINOR BRUISING AS A RESULT. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD WAS DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE ISSUE. THE FAILURE MILEAGE WAS UNAVAILABLE. THE CURRENT MILEAGE WAS 93,572. UPDATED 1/2/13 *CN UPDATED 01/09/13
Nov 21, 2012
ON SEVERAL OCCASIONS, AFTER PRESSING BUTTON TO CLOSE REAR SLIDING DOOR, I TRIED TO STOP THE DOOR FROM CLOSING BY PUTTING MY BODY IN THE WAY. THE DOOR KEPT CLOSING AND DID NOT AUTOMATICALLY STOP AND REVERSE LIKE IT IS SUPPOSE TO. THIS NOT ONLY HAPPENED TO ME, BUT ALSO BOTH OF MY SMALL CHILDREN. IN EVERY CASE, THEY WERE SCARED TO TEARS BECAUSE OF THE PRESSURE PUT ON THEM PRIOR TO THE DOOR REVERSING LIKE IT IS SUPPOSED TO. AS AN ADULT FEMALE, I WAS ALSO SCARED BY THE AMOUNT OF PRESSURE THE DOOR PLACED ON ME AS I PUSHED BACK TO TRY AND STOP IT BEFORE IT WOULD FINALLY REVERSE. *TR
Dec 15, 2009
TL*THE CONTACT OWNS A 2007 GRAND CARAVAN. WHILE THE CONTACT WAS EXITING THE PASSENGER SIDE REAR SLIDING DOOR IT SUDDENLY BEGAN TO CLOSE ON ITS OWN. A CHILD'S HEAD BECAME STUCK IN BETWEEN THE SLIDING DOOR AND THE FRAME OF THE VEHICLE. THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 71000.
Nov 17, 2009
+ 2 more complaints for this component
ENGINE
6 complaints
AS I WAS DRIVING IN TOWN THE VEHICLE STARTED RUNNING VERY ROUGH, I PULLED OVER INTO A PARKING LOT AND THEN IT WOULDN'T RUN AT ALL. I HAD IT TOWED TO AN AUTO REPAIR PLACE. THEY REPLACED A SENSOR. THAT DID NOT FIX THE PROBLEM, SO AFTER A FEW WEEKS THEY FINALLY DIAGNOSED IT AS NEEDING A VALVE JOB. I BOUGHT THIS VEHICLE NEW IN 2007 AND HAD IT REGULARLY SERVICED.
Sep 09, 2019
CAR STALLS AFTER YOUR FILL THE GAS TANK THIS IS A KNOWN ISSUE WITH SEE CASE #66165038FL DOES SOMEONE HAVE TO DIE ? THIS IS A SAFETY CONCERN YOUR CAR COULD DIE IN TRAFFIC
Dec 12, 2016
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHILE DRIVING 25 MPH AND ATTEMPTING TO MAKE A TURN, THE POWER STEERING FAILED AND THE BATTERY AND TEMPERATURE GAUGE LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE TIMING BELT FRACTURED AND THE TIMING CHAIN AND ENGINE COVER NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 153,000.
May 20, 2016
ENGINE DIES AFTER FILLING UP GAS TANK BECAUSE OF A FAULTY VAPOR/LIQUID SEPARATOR VALVE. AFTER FILLING UP AND DRIVING FOR LESS THAN A 1/4 MILE THE ENGINE WILL STALL IN TRAFFIC SEVERAL TIMES.
Jan 21, 2016
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHILE MAKING A RIGHT TURN AT VARIOUS SPEEDS, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 115,000. THE VIN WAS UNAVAILABLE.
Dec 10, 2015
+ 1 more complaint for this component
WHEELS
5 complaints
WHILE TRAVELING ON I-84 IN IDAHO THE TIRE TREAD SEPARATED FROM THE TIRE. THIS WAS THE SECOND TIRE TO FAIL. THE TIRES WERE COOPER CS5 GT 98T SERIAL NUMBER U96V1CW1617
Sep 16, 2020
WHILE DRIVING AT 35 MPH OR LESS FOR LESS THAN 5 MINUTES IN CITY TRAFFIC, MY RIGHT REAR TIRE BLEW OUT. FIRESTONE FR710. PURCHASED 11/30/15
Feb 28, 2019
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT AFTER TAKING THE VEHICLE FOR AN OIL CHANGE, THE TIRE VALVE STEM IN THE TREAD HOUSING FRACTURED. AS A RESULT, THE FRONT DRIVER SIDE TIRE DEFLATED AND THE TIRE PRESSURE SENSOR INDICATOR WARNING LIGHT ILLUMINATED. THE REPAIR SHOP REPLACED THE TIRE PRESSURE INDICATOR. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 76,000.
Aug 24, 2012
THE REAR WHEEL BEARINGS (BOTH DRIVERS SIDE AND PASSENGER SIDE) ON MY 2007 DODGE GRAND CARAVAN WITH 56,000 WERE FOUND TO BE LOOSE WHILE MY CAR WAS GETTING ITS BRAKES REPLACED. UNSURE IF I WAS JUST BEING TOLD THAT MY REAR WHEEL BEARINGS WERE NEEDING TO BE REPLACED, I TOOK IT TO AN INDEPENDENT GARAGE. I WAS INFORMED MY REAR WHEEL BEARINGS WERE SO BAD, I PROBABLY SHOULD NOT DRIVE IT ALL WITH MY SON. THEY WERE REPLACED AT COST OF $605. WHEN I LOOKED UP REAR WHEEL BEARINGS AND THEIR FUNCTIONS, IT MADE ME REALIZE THIS IS HUGE SAFETY ISSUE AND IT WAS BOTH OF THEM. *TR
Feb 14, 2010
TL*THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHILE DRIVING APPROXIMATELY 45 MPH, THE CONTACT FELT AN IMBALANCE IN THE FRONT END OF THE VEHICLE. AS HE ATTEMPTED TO DECELERATE AND PULL OVER, THE FRONT PASSENGER SIDE WHEEL DETACHED AND ROLLED DOWN THE ROAD. THE FAILURE OCCURRED WHILE DRIVING 15 MPH. HE STATED THAT THE LUG STRUTS FRACTURED AND THE VEHICLE WAS TOWED TO THE DEALER. THE DEALER WAS UNABLE TO EXPLAIN THE CAUSE OF FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 5,500.
Aug 06, 2007
FUEL SYSTEM, GASOLINE
5 complaints
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. ON SEVERAL OCCASIONS, THE VEHICLE STALLED AFTER BEING FILLED WITH FUEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE VAPOR LIQUID SEPARATOR VALVE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE FAILURE RECURRED SIX TIMES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 65,000. ....UPDATED 08/29/16 *BF UPDATED 08/31/16.*JB
Jul 15, 2016
AFTER REFUELING, VEHICLE STALLED WHEN ACCELERATING FROM STOP LIGHT. WAS ABLE TO IMMEDIATELY RESTART. THIS HAPPENS APPROXIMATELY 50% AFTER REFUELING AND SEEMS TO BE MORE COMMON/PRONOUNCED WHEN MAKING TURNS AT INTERSECTIONS SOON AFTER REFUELING. SEEMS TO BE LESS FREQUENT IF I REMAIN STOPPED, WITH ENGINE OFF, AT THE GAS STATION (E.G. GO INSIDE FOR PURCHASE). VERY AGGRAVATING AND CONCERNED FOR SAFETY IF STALL OCCURS IN HIGH TRAFFIC AREA. *TR
Feb 16, 2015
THIS IS A DEFECT PETITION FILED PURSUANT TO 49 U.S.C. 30162. OUR 2007 GRAND CARAVAN SXT HAS ABOUT 44,000 MILES ON IT AND IT HAS BEGUN STALLING AFTER REFUELING. THIS ONLY HAPPENS WHEN THE FUEL TANK IS REFUELED TO FULL CAPACITY. THE PROBLEM STARTED ABOUT A MONTH AGO. TODAY, MY WIFE (WITH KIDS IN CAR) STALLED ON THE HIGHWAY. THE DANGER WAS THAT SHE WAS ON A TURN AND THE STEERING WHEEL BECAME IMPOSSIBLE FOR HER TO TURN IT. THIS IS A MAJOR SAFETY ISSUE, AND MY HOPE IS THAT CHRYSLER MAKES GOOD ON A DEFECTIVE PART. (I SEE THEY DID THAT AFTER A GOV'T INVESTIGATION OF A SIMILAR NATURE FOR OTHER CARS...AFTER AN INVESTIGATION BY NHTSA!) ***THIS IS A WIDESPREAD ISSUE FOR VEHICLES FROM 2004 TO 2013. SEE THREAD BELOW FOR REFERENCE; HTTP://EN.ALLEXPERTS.COM/Q/CHRYSLER-REPAIR-807/F/STALLING-REFUELING.HTM
Jul 02, 2014
EVERYTIME I FUEL MY DGC, AFTER I START UP, THE ENGINE WILL SPUTTER AND STALL OUT, EVEN OUT IN TRAFFIC. I HAVE PUT IT IN PARK, RESTART (IT RESTARTS ROUGH), AND THEN REV THE ENGINE A FEW TIMES TO WORK OUT SPUTTERS AND ROUGHNESS. *TR
Oct 19, 2013
AFTER FILLING UP THE FUEL TANK, THE CAR DIES WHILE DRIVING A FEW MINUTES LATER. DEALERSHIP SAID THE FUEL TANK NEEDED TO BE REPLACED AND CHARGED ME $766.55. THE CALLED IT A NON SERVICEABLE CHECK VALVE IN THE FUEL TANK WHICH ALLOWS LIQUID FUEL INTO EVAPORATE LINE AFTER REACHING A CERTAIN LEVEL. ONCE THE VEHICLE IS STARTED THE PCM PURGES THE EVAPORATE SYSTEM TO BURN THE VAPORS AND EXPOSURE THE CATALYST WARM UP SYSTEM. AT THIS TIME THE LIQUID FUEL IN THE EVAPORATE LINE IS SUCKED INTO THE ENGINE INTAKE MANIFOLD AND CAUSES THE ENGINE TO STALL. THIS IS A SERIOUS SAFETY ISSUE BECAUSE THE CAR COULD BE ON THE ROAD. WHEN IT STALLS IT COULD EASILY CAUSE AN ACCIDENT. CHRYSLER SHOULD FIX THIS BEFORE PEOPLE ARE INJURED. *TR
Sep 25, 2011
UNKNOWN OR OTHER
3 complaints
WHEVER I FILL UP THE GAS TANK, THE CAR STARTS TO STALL AND JERKS AND STOPS ALL THE WAY. IT DISPLAYS ENGINE LIGHT AND GOES INTO CRUISE MODE. I HAVE TO TURN IT OFF N BACK ON AND STILL JERKS UNTIL THE FUEL IS LITTLE EMPTY. WHEN I DON'T FILL IT FULL THEN IT DOESN'T DO THIS
Jan 11, 2020
VEHICLE LEAKS ON PASSAGENER SIDE.WHEN IT RAINS OR U RUN IT THROUGH THE CAR WASH WATER SOMETIMES RUNS BEHIND THE DASH UNTO THE FLOOR. WE HAVE TRIED TO FIND THE LEAK TO NO AVAIL. CARPET HAS FORMED MILDEW FROM THE LEAK. CANNOT GET THE CO. TO FIX OR TELL US WHERE THE LEAK IS.
Mar 21, 2018
SUBSTANDARD BRAKING SYSTEM ON THE 2007 DODGE GRAND CARAVAN
Mar 24, 2010
SERVICE BRAKES
3 complaints
BRAKES PEDAL GOING TO THE FLOOR WHEN STOPPING AT INTERSECTION! THIS JUST OCCURRED OR STARTED YESTERDAY! I AM TAKING TO A MECHANIC IN THE MORNING TO EVALUATE.
Jul 11, 2019
I WAS DRIVING MY VEHICLE AND MY ANTI-LOCK BRAKES SYSTEM RESPONDED TO THE ICE ON THE ROAD AND I PROCEEDED TO PUMP MY BRAKE PEDAL TO SLOW THE VEHICLE DOWN AND THEN I NOTICED THAT THE BRAKE PEDAL WOULD GO ALL THE WAY TO THE FLOOR TO STOP THE VEHICLE SO I GOT HOME AND CHECKED THE BRAKE LINES FOR LEAKS AND DIDN'T FIND ANY AND THAT MY BRAKE RESERVOIR WAS FULL. *TR
Dec 19, 2014
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE PARKING BRAKE CABLE BECAME FRACTURED WHEN ENGAGED, CAUSING THE VEHICLE TO SLIGHTLY ROLL AWAY IN REVERSE. THE CONTACT SHIFTED INTO PARK TO STOP THE VEHICLE. THE CONTACT CALLED THE DEALER BUT NO REPAIRS WERE PERFORMED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 94,000.
Nov 19, 2013
EXTERIOR LIGHTING
3 complaints
HEADLIGHTS AND DASH LIGHTS RANDOMLY SHUT OFF WHILE IV AM DRIVING DOWN THE HIGHWAY STRAIGHTAWAY IN THE DARK I MONKEY WITH HEADLIGHT SWITCH AND THE LIGHTS COME BACK ON. THIS HAS HAPPENED TO ME ABOUT 8 TIMES IN THE LAST YEAR. BUT RECENTLY IT HAS GOTTEN WORSE.
Feb 27, 2017
TL* THE CONTACT OWNS 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE INTERIOR LIGHTS ON THE FRONT DOME WIRING SYSTEM BURNT OUT. THE INSTRUMENT PANEL WIRING SYSTEM WAS PARTIALLY BURNT OUT CAUSING THE LIGHT TO ILLUMINATE ON AND OFF. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 98,000.
Jan 28, 2013
HEADLIGHTS WILL NOT COME ON INTERMITTENTLY. HEADLIGHTS TURN OFF WHILE DRIVING. *TR
Jul 01, 2009
ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM
3 complaints
VEHICLE STALLS INTERMITTENTLY WHILE DRIVING SHORTLY AFTER FILLING UP WITH FUEL. VEHICLE CONTINUES TO STALL PERIODICALLY WITHOUT ANY KNOWN CONSISTENCY. DURING THE STALL, THE ENGINE CUTS OUT AND THE STEERING WHEEL LOCKS UP. THIS HAS OCCURRED SEVERAL TIMES IN THE PARKING LOT AFTER FILLING UP AND WHILE ENTERING THE ROADWAY AFTER FILLING UP. THIS A VERY DANGEROUS AND SERIOUS CONCERN FOR WHEN A LOSS OF POWER OCCURS ON THE ROADWAY SERIOUS AND POTENTIALLY FATAL ACCIDENTS MAY OCCUR. *TR
Apr 27, 2015
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE VEHICLE STALLED AFTER THE VEHICLE WAS REFUELED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000. THE VIN WAS NOT AVAILABLE.
Mar 30, 2015
25 MPH, THE VEHICLE STALLED WITHOUT WARNING. THIS FAILURE OCCURRED TWICE AFTER THE VEHICLE WAS FILED WITH FUEL. THE VEHICLE WAS TAKEN TO THE INDEPENDENT MECHANIC FOR A DIAGNOSTIC TESTING, HOWEVER THEY COULD NOT DUPLICATE THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 88,000. RG *TR
Sep 11, 2014
ELECTRICAL SYSTEM,EXTERIOR LIGHTING
3 complaints
THE INTERIOR IN THE FRONT OF THE VEHICLE WENT OUT. WHEN I TOOK IT OUT TO REPLACE IT, AND IT WAS MELTED ON ONE SIDE. THAT HAPPENED TO ME WITH THE OTHER SIDE OF THE FRONT INTERIOR LIGHTS, AROUND 2011 AND WHEN I WENT TO THE DEALERSHIP I WAS TOLD I WOULD HAVE TO BUY THE WHOLE ASSEMBLY AT A COST OF ABOUT $150.00 I THINK. I ASKED THEN IF THERE HAD BEEN A RECALL ON THIS AND WAS TOLD NO. I ASKED WHAT WOULD CAUSE THE LIGHT TO MELT AND HE SAID HE DID NOT KNOW. I LEFT IT AS I STILL HAD THE ONE ON THE DRIVERS SIDE BUT NOW I DO NOT HAVE EITHER AND THERE ISN'T ANY LIGHT IN THE FRONT OF THE CAR WHEN OPENING THE DRIVERS OR FRONT PASSENGER DOOR. PLEASE ADVISE ME IF THIS HAS BEEN A PROBLEM AND OR WHAT CAN I DO ABOUT IT. *JS
Dec 03, 2014
HEAD LIGHTS STOPPED WORKING. NOT SIMPLE BULB REPLACEMENT, MAJOR ELECTRICAL PROBLEM IN POWER DISTRIBUTION SYSTEM. *TR
Nov 23, 2012
THE HEADLIGHTS INTERMITTENTLY SHUTOFF OR WILL NOT TURN ON WHILE DRIVING. I HAVE REPLACED THE BULBS, CHECKED FOR A LOOSE CONNECTIONS, AND CHECKED THE FUSES MANY TIMES. THIS IS OKAY DURING THE DAY, HOWEVER I LIVE OUT IN THE COUNTRY 15 MINUTES FROM THE NEAREST TOWN. I CANNOT DRIVE AT NIGHT WITHOUT HEADLIGHTS OR WITH THE POSSIBILITY THAT THEY WILL SHUTOFF WHILE DRIVING. THIS IS EXTREMELY DANGEROUS. I HAVE BEEN LUCKY SO FAR THAT NOTHING SERIOUS HAS HAPPENED BUT THIS IS A PROBLEM THAT MUST BE FIXED! MY WIFE AND 7 MONTH OLD CHILD USE THIS VEHICLE THE MOST AND I CAN'T FATHOM THE IDEA OF THEM BEING INJURED DUE TO THIS PROBLEM. OTHERS HAVE SUGGESTED A FAULTY HEADLIGHT SWITCH. I HAVE NOT HAD THE TIME TO TAKE THE VEHICLE IN TO THE DEALERSHIP TO HAVE IT INSPECTED. *TR
Oct 09, 2010
STEERING
3 complaints
I HAVE A 2007 DODGE GRAND CARAVAN. WHILE NOT A GM VEHICLE, I HAVE EXPERIENCE THE SAME ISSUE WITH THE IGNITION AS HAS BEEN REPORTED ON THE GM VEHICLES. I HAVE HAD SEVEN INCIDENTS. THE ISSUES INVOLVES VEHICLE LOSING ALL POWER. ALL GAUGES WILL DROP TO ZERO AND STEERING WILL BE LOST. I HAVE HAD TO SWITCH THE VEHICLE OVER TO NEUTRAL AND PULL OVER TO THE SIDE OF THE ROAD. UPON SHUTTING OFF THE VEHICLE AND RESTARTING, THE VEHICLE STARTS FINE. AFTER HEARING ABOUT THE GM RECALL, I TOOK ALL EXCESS KEYS OFF OF MY KEY CHAIN. I HAVE NOT ENCOUNTERED THE PROBLEM SINCE. HOWEVER, THIS IS VERY CONCERNING TO ME. AT ONE TIME, I WAS TURNING AROUND A CIRCULAR MONUMENT AND ALMOST COULD NOT MAKE IT TO THE SIDE OF THE ROAD IN NEUTRAL. I FEAR THAT THIS IGNITION ISSUE IS AFFECTING MORE VEHICLES THAN JUST GMS. *TR
Mar 31, 2014
2007 DODGE CARAVAN WITH 37,000 MILES WENT FOR ANNUAL INSPECTION. FOUND BOTH OUTER TIEROD ENDS WERE WORN OUT AND UNABLE TO PASS INSPECTION. VAN WAS NEVER ABUSED, NOR PUT INTO SEVERE SERVICE. FOUR PREVIOUS VANS DATING BACK TO 1991 HAD OVER 100,000 MILES AND NEVER THIS PROBLEM. THEREFORE, THE MATERIAL MUST BE DEFECTIVE. DEALER SAYS IT IS NOT ABNORMAL FOR THIS EARLY REPAIR. I THINK CHRYSLER USED DEFECTIVE MATERIALS. *TR
May 26, 2010
WHEN I RIDE THROUGH PUDDLES OF WATER, I LOOSE THE ABILITY TO STEER MY VEHICLE. I WAS TURNING THE CORNER ENTERING ONTO A MAIN ROAD THAT HAD A MODERATE SIZE PUDDLE OF WATER. I LOSS THE ABILITY TO STEER MY VAN AND ALMOST RAN INTO THE MEDIAN. THE LOSS WAS ONLY FOR A FEW SECONDS BUT LONG ENOUGH FOR ME TO LOOSE CONTROL OF MY VAN. I COULD NOT STEER MY VEHICLE AFTER A VERY HARD GUST OF RAIN SHOWERED MY VEHICLE AS I WAS YIELDING BEFORE ENTERING A MAIN HIGHWAY. AFTER PROCEEDING ONTO THE HWY I HAD TO STOP AND WAIT SEVERAL SECONDS BEFORE BEING ABLE TO STEER THE VEHICLE. I HAVE HAD ONE OTHER OCCURRENCE AFTER SPLASHING INTO A VERY SMALL PUDDLE OF WATER ENTERING INTO THE DEVELOPMENT THAT I LIVE IN. I WAS TRAVELING VERY SLOWLY AS I WAS APPROACHING THE GUARD GATE. I HAD TO WAIT AT LEAST 20 SECONDS BEFORE BEING ABLE TO STEER MY VEHICLE. EACH OCCURRENCE THE LENGTH OF TIME THAT I LOOSE STEERING SEEMS TO INCREASE. EACH TIME IT SEEMS THE WATER SPLASHES ON THE PASSENGER SIDE OF THE VEHICLE. THIS SEEMS TO HAVE BECOME A PROBLEM WITHIN THE LAST YEAR. I AM VERY CONCERNED AND WILL BE CONTACTING MY DEALER. *TR
Mar 12, 2010
TIRES,WHEELS
3 complaints
THE TPMS FAILED. THE VALVE STEM CRACKED OFF WHEN ADDING AIR. AIR WAS BEING ADDED BECAUSE THE VALVE STEM WAS LEAKING, AND THE TIRE WAS NEAR FLAT, AND I WANTED TO TAKE IT TO A REPAIR SHOP. THIS IS THE SECOND TPMS VALVE FAILURE I HAVE HAD. FORTUNATELY, BOTH OCCURRED AT A STANDSTILL. I SEE TALES ON THE INTERNET OF FAILURE AT HIGH SPEED, FOLLOWED BY VARY RAPID DECOMPRESSION AND TIRE FAILURE. EXPENSIVE, IF NOT UNSAFE. IN MY OWN CASE, WITH OVER 50 YEARS DRIVING EXPERIENCE AND 2 YEARS AS A MECHANIC, I HAVE NEVER SEEN A VALVE STEM FAILURE BEFORE. NOW, I HAVE TWO. EXPERT MECHANICS ARE ADVISING TO REPLACE THEM WITH STANDARD VALVES, AND I WILL. FROM AN ECONOMIC VIEW, THE SEVERAL FAILURES OF THE STEMS, AND STEM FAILURES, HAVE COST ME ABOUT 6 CENTS PER MILE. GAS HAS COST ME ABOUT 18 CENTS PER MILE (AT TODAYS COST). THUS, THE TPMS SYSTEM MAINTENANCE IS ABOUT 1/3 OF THE GAS COST. I DOUBT VERY SERIOUSLY THAT THE TPMS SYSTEM SAVES THAT MUCH IN GASOLINE USE. BUT FROM A SAFETY PERSPECTIVE, I AM NOT WILLING TO RISK SUDDEN DEPRESSURIZATION FOLLOWED BY TIRE DESTRUCTION AT HIGHWAY SPEEDS. THUS, I WILL BE PULLING THOSE OUT BEFORE MY NEXT HIGHWAY TRIP. AFTER TALKING WITH SEVERAL MECHANICS, LOOKING AT THE DESIGNS, AND LOOKING AT EXPERIENCES OF OTHERS, I CONCLUDE THAT TPMS IS A GOOD IDEA WITH A BAD EXECUTION. IF THEY ARE NOT (NEARLY AS SECURE) AS OLDER VALVE STEMS, THEY SHOULD BE DE-MANDATED. FINALLY, I NOTE THAT AT LEAST SOME OF THESE HAVE MERCURY IN THE PACKAGE AS A ROTARY SWITCH. AS MUCH AS WE ARE SPENDING TO REMOVE MERCURY FROM THE ENVIRONMENT . . . *TR
Feb 26, 2014
SPARE TIRE WINCH CARRIER FAILED CAUSING SPARE TIRE TO COME LOOSE. SPARE TIRE STRUCK THE LEFT REAR WHEEL AND CAUSED A BLOW OUT. INSPECTION OF THE WINCH REVEALED A FRAYED STEEL CABLE WITH THE ENTIRE "DOG BONE", CARRIER ASSEMBLY, AND SPARE TIRE MISSING. SPARE TIRE AND CARRIER ASSEMBLY WAS NOT ABLE TO BE RECOVERED. *TR
Jan 26, 2013
THE TIRE PRESSURE MONITORING SYSTEM HAS EXPERIENCED A FAILURE ON THE LEFT FRONT TIRE WHILE TRAVELING UNDER 30MPH, COULD HAVE CAUSE POTENTIAL HAZAROUS SITUATION IF OCCURRED AT HIGHER RATE OF SPEED. *TR
Dec 03, 2011
VEHICLE SPEED CONTROL
3 complaints
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE TRAVELING 50 MPH, THE ACCELERATOR PEDAL SEIZED CAUSING THE VEHICLE TO ACCELERATE ERRONEOUSLY. THE CONTACT WAS ABLE TO MANEUVER THE VEHICLE TO THE SIDE OF THE ROAD WHERE IT STARTED TO SHAKE AND STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 68,500.
Sep 17, 2012
WE HAVE A 2007 DODGE CARAVAN SXT. ON TWO SEPARATE OCCASION, I WAS AT AN INTERSECTION, WITH MY FOOT ON THE BRAKES WAITING FOR THE LIGHT TO CHANGE, AND THEN THE IDLING OF THE RPM STARTED TO CLIMB VERY HIGH, AND THE VAN STARTED TO VIBRATE, THEN WHEN THE LIGHT CHANGED MY ACCELERATOR PEDAL WOULD NOT ENGAGE, IT WAS STUCK FOR A GOOD 5 MINUTES. AFTER WHICH I KEPT PRESSING THE PEDAL, AND THEN IT FINALLY LOOSEN, I HEARD A SOMETHING POPPING LOOSE WHEN IT HAPPENED AND THEN THE ACCELERATOR ZOOMED SO FAST WHEN DEPRESSED. THE SECOND TIME IT HAPPENED, SAME THING HAPPENED AND THEN IT GOT STUCK AGAIN. THE DEALER SERVICE CENTER, SAID THAT THEY COULD NOT LOCATE THE PROBLEM. HAS ANYONE ELSE ENCOUNTERED THIS TYPE OF PROBLEM. I KNOW THAT WHEN I DESCENDING A STEEP HILL, I CAN FEEL ALOT OF VIBRATION ON MY BRAKES. ALSO MY SIDE DOORS DOES NOT OPEN WITH THE HANDLE OR THE KEY REMOTE, OR OVERHEAD REMOTE. YOU NEED TO PLAY AROUND WITH THE DOOR HANDLE ON THE OUTSIDE FOR AWHILE BEFORE YOU CAN GET IT OPENED. *TR
Feb 17, 2011
TL*THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT STATED THAT THE ACCELERATOR PEDAL BECAME STUCK INTERMITTENTLY CAUSING UNINTENDED ACCELERATION. SHE HAD TO APPLY EXTREME PRESSURE TO THE BRAKE PEDAL TO PREVENT A CRASH FROM OCCURRING. SHE TOOK THE VEHICLE TO THE DEALER WHO ADVISED HER THAT THE PEDAL WAS COVERED WITH RUST AND NEEDED TO BE REPLACED. SHE HAD NOT SPOKEN WITH THE MANUFACTURER TO-DATE. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CURRENT MILEAGE WAS 75,428. THE FAILURE MILEAGE WAS APPROXIMATELY 72,000.
Feb 09, 2010
STEERING,SUSPENSION
3 complaints
I PREVIOUSLY SUBMITTED A COMPLAINT ABOUT MY REAR WHEEL BEARINGS. MY ABS LIGHT IS ON AGAIN SO I TOOK IT THE GARAGE. I AM TOLD MY RIGHT OUTER TIE ROD AND THE SWAY BAR KIT NEEDS TO BE REPLACED. I HAVE ALREADY REPLACED THE LEFT OUTER TIE ROD ABOUT 10,000 MILES AGO. THE SUSPENSION OF THIS VAN IS HORRIBLE AND IT IS A FAMILY CAR. I CARRY MY FAMILY IN THIS CAR THAT COULD LOOSE A TIRE, FLIP OVER, OR LEAVE ME STRANDED IN THE MIDDLE OF THE ROAD. I AM A MOTHER WHO DOESN'T USE THE VAN FOR ANYTHING OTHER THAN ORDINARY USE. I AM NOT BAJA OR CAUSING ANY STRESS ON THE SUSPENSION TO CAUSE ALL THESE PROBLEMS. CURRENT MILEAGE IS 64,000. *TR
May 22, 2010
CONTINUAL POWER STEERING PROBLEM WITH VEHICLE AND METALLIC SOUND FROM FRONT SUSPENSION. I TOOK TO RICHMOND DODGE IN RICHMOND, MI FOR SERVICE 3 TIMES FOR SAME COMPLAINT. ON LAST SERVICE, LEARNED TIE RODS, BALL JOINTS, AND STRUT BEARING DEFECTIVE. POWER STEERING STILL MAKING NOISE AND HARD TO STEER. TOTAL SHOP TIME 10 DAYS. *TR
Aug 22, 2009
1-TOOK CHRYSLER 2007 GRAND CARAVAN FOR REPAIR, JULY 2, 2009, FOR BRAKE REPAIR AND TUNEUP. REPAIR MAN NOTICED THE FRONT TIE-RODS WERE OF MORE IMMEDIATE CONCERN. HE SAID HE NOTICED SAME CONDITION OF DAMAGED/BENT TIE RODS ON OTHER CHRYSLER MINI VANS (NOT SURE IF OTHER CHRYSLER VEHICLES AS WELL). HE EVEN QUESTIONED WHETHER THERE WAS AN IMMANENT RECALL. I DID JUST WRITE TO CHRYSLER EXPRESSING CONCERN ON TIE RODS. 2- THE FAILURE IS THE FRONT TIE RODS (NOT SURE ON REAR) WHICH NOW MAKES SENSE AS MY FRONT TIRES ARE PREMATURELY WORN. DID THE TIE RODS ALSO CAUSE THE BRAKES TO PREMATURELY WEAR? I HAVE 45K MILES ON VEHICLE (NORMAL DRIVING CONDITIONS)AND AM NOW ON 2ND BRAKE REPAIR (ROTORS AND PADS). NOT 100% CLEAR IF BRAKES AFFECTED BY TIRE RODS DAMAGE BUT PREMATURE TIRE CONDITION IS, ACCORDING TO MECHANIC. CONSEQUENCES OF FRONT TIE ROD DEFECT COULD BE SERIOUS ACCIDENT WHILE DRIVING. 3- ACTION ITEM: I WILL HAVE REPAIR PLACE REPAIR FRONT BRAKES THEN BRING VAN BACK IN ONE WEEK TO REPAIR THE FRONT TIE RODS ($150). THEN A WEEK LATER GET NEW FRONT TIRES. COULDN'T AFFORD ALL THREE AT ONCE. *TR THANK YOU FOR ANY HELP/GUIDANCE
Jul 02, 2009
SEATS
2 complaints
TAKARA RECALL- MY VEHICLE WAS PARKED AT A STORE IN WAS WORKING IN, I WENT OUT TO TAKE A BREAK AND HAD THE SEAT WARMER ON HIGH BECAUSE MY BACK WAS HURTING. I STARTED SMELLING BURNING RUBBER, SO I TURNED IT OFF. UPON EXITING MY VEHICLE THERE WERE TWO HOLES BURNED INTO MY DRIVERS SEAT. I HAD USED THE SEAT WARMER NUMEROUS TIMES PRIOR TO THIS AND HAD NO PROBLEMS. I BELIEVE IF I HADN'T TURNED THE SEAT WARMER OFF MY VAN AND MYSELF PROBABLY WOULD HAVE BEEN ON FIRE.
Dec 27, 2018
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE VEHICLE WAS RUNNING FOR APPROXIMATELY 2 HOURS WITH THE STOW AND GO REAR SEATS DEPRESSED DOWN INTO THE FLOOR. WHILE PARKED, THE CONTACT TOUCHED THE METAL BARS THAT WERE EXPOSED ON THE BACK OF THE SEATS AND WAS BURNED. THE MANUFACTURER WAS NOTIFIED AND INFORMED HIM THAT THEY WOULD SEND AN INVESTIGATOR TO EXAMINE THE VEHICLE. THE VEHICLE WAS NEITHER EXAMINED NOR REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 140,000. UPDATED 11/16/10. *LJ
Aug 16, 2010
ELECTRICAL SYSTEM,AIR BAGS
2 complaints
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V373000 (AIR BAGS, ELECTRICAL SYSTEM); HOWEVER, THE PART NEEDED TO PERFORM THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
Feb 24, 2016
AIRBAG WARNING LIGHT CAME ON AND TOOK IT TO THE DEALER. THE DEALER STATED THAT THE FRONT IMPACT SENSORS WENT BAD BECAUSE THE WIRE HARNESS CORRODED AND CAUSED THE OPEN CIRCUIT, CAUSING THE AIRBAG WARNING LIGHT TO COME ON CAUSING DAMAGE TO THE COMPONENTS. *TR
Oct 07, 2011
AIR BAGS,SEAT BELTS
2 complaints
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHILE DRIVING AT 65 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FRONT DRIVER SIDE SEAT BELT LATCH NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO A DEALER WHO DIAGNOSED THAT THE BLADDER PRESSURE SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 74,000.
Jun 01, 2015
TL*THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHILE DRIVING 30 MPH, A VEHICLE CRASHED INTO THE REAR DRIVER'S SIDE OF THE CONTACT'S VEHICLE. THE VEHICLE SPUN, ROLLED OVER INTO A DITCH, AND LANDED ON ITS ROOF. THE SIDE AIR BAGS FAILED TO DEPLOY AND THE SEAT BELTS DID NOT LOCK. THE CONTACT WAS INFORMED THAT WHEN HE PURCHASED THE VEHICLE, THE SEAT BELTS WOULD LOCK IN CASE OF A ROLLOVER. THE DRIVER AND FRONT PASSENGER WERE EJECTED FROM THE SEAT BELTS AND STRUCK THEIR HEADS. THE DRIVER SUSTAINED A MISALIGNED BACK AND UPPER AND LOWER SPINAL STRAIN. THE DRIVER SUSTAINED A CUT HAND AND UPPER AND LOWER SPINAL STRAIN. THE VEHICLE WAS TOWED AND DETERMINED TO BE DESTROYED. A POLICE REPORT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE 32,000.
Feb 08, 2008
FUEL SYSTEM, GASOLINE,ENGINE
2 complaints
WHEN IT FIRST BEGAN THE VAN WOULD STALL AND SKIP UPON ACCELERATION BETWEEN 20-50 MPH. NOW THE VAN STALLS AND/OR SKIPS AT ANY POINT OF ACCELERATION. THE ENGINE LIGHT COMES ON RIGHT AFTER THERE IS FUEL ADDED TO THE TANK AND THIS IS WHEN THE STALLING IS THE WORSE. THE ENGINE LIGHT ALSO COMES ON WHEN THERE IS1/4 TANK OF GAS LEFT AND THE DISTANCE TO EMPTY NUMBER JUMPS AROUND WHEN THERE IS LESS THAN 1/4 OF A TANK. *TR
Dec 29, 2014
VEHICLE STALLS IMMEDIATELY AFTER FILLING GAS TANK COMPLETELY. I LET PUMP TURN OFF AUTOMATICALLY AND DO NOT OVERFILL. HAS HAPPENED REPEATEDLY IN TRAFFIC AND IS DANGEROUS. AFTER A FEW MILES, NO MORE STALLING OR SPUTTERING. LOTS OF REPORTS OF THIS PROBLEM WITH DODGE/CHRYSLER VEHICLES ONLINE BUT COMPANY CLAIMS NO KNOWLEDGE OF PROBLEM. FIX IS TO REPLACE FUEL TANK AND ATTACHED PARTS. *TR
Feb 04, 2014
ELECTRICAL SYSTEM,LATCHES/LOCKS/LINKAGES
2 complaints
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHEN THE FRONT DRIVER SIDE DOOR WAS LOCKED WITH EITHER THE KEY FOB OR MANUALLY, AN ABNORMAL NOISE EMITTED FROM THE DOOR PANEL. WHEN UNLOCKING THE DOOR FROM THE OUTSIDE, THE DOOR FAILED TO UNLOCK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 10,000. UPDATED 02/02/15*LJ UPDATED 6/8/2015 *JS
Dec 10, 2014
THE POWER LOCKS HAVE QUIT WORKING ON THE REAR SLIDING DOORS WHERE MY CHILDREN SIT. NO WAY TO UNLOCK DOORS FROM OUTSIDE TO REMOVE CHILDREN IN CASE OF ACCIDENT. THE DOORS WILL NOT OPEN FROM THE INSIDE UNLESS MANUALLY PULLED UP. THIS IS A VERY VERY COMMON PROBLEM WITH DODGE. ONLY ONE MANUAL KEY HOLE TO UNLOCK VAN ON DRIVERS DOOR. THIS IS VERY DANGEROUS FOR PASSENGERS ESPECIALLY CHILDREN. *TR
Feb 19, 2013
STEERING,ENGINE,FUEL/PROPULSION SYSTEM
2 complaints
ON APPROXIMATELY 04/07/2014 THE VAN WAS FILLED UP WITH GAS, I TOOK THE NOZZLE OUT WHEN IT SHUT OFF AND DID NOT PUT ANY EXTRA GAS INTO TANK. I STARTED UP THE VAN TO EXIT THE STATION WE DROVE ABOUT 100 YARDS AND THE VAN JERKED WITH A KNOCKING SOUND TWICE AND STALLED. I STARTED THE VAN BACK UP, WHEN IT DID START THE IDLE WAS ROUGH AND LOW. I HELD MY FOOT ON THE GAS PEDDLE TO SLIGHTLY RAISE THE RPM'S FOR ABOUT 30 SECONDS BEFORE WE PROCEEDED. IT TOOK A COUPLE OF MILES BEFORE THE VAN SEEMED TO BE ABOUT NORMAL. THIS HAS HAPPENED TWO OTHER TIMES SINCE THEN. ANOTHER COMPLAINT, THE FRONT BRAKES SQUEAK EVERY TIME YOU APPLY THEM. *TR
Sep 19, 2014
WHEN I FILL UP MY VAN, THE VEHICLE WILL START HOWEVER AFTER A FEW MINUTES AND I AM ON THE HIGHWAY THE CAR COMPLETELY SHUTS OFF. HAVE HAD TO SEVERAL MECHANICS LOOK AT THE VAN, AND NO ONE KNOWS WHAT THE ISSUE IS. I TRY TO RIDE AROUND THE GAS STATION PARKING LOT TO INSURE THE VAN IS GOING TO RUN BECAUSE I HAVE HAD SEVERAL CLOSE CALLS WHEN THE VEHICLE SHUTS DOWN WHEN I AM TRYING TO CROSS TRAFFIC. I WILL THEN HAVE NO BRAKES, POWER STEERING, ETC. THE VAN SHUTS COMPLETELY OFF. I USUALLY ABLE TO RESTART THE VEHICLE. THIS IS A VERY UNSAFE ISSUE. *TR
Sep 10, 2014
LATCHES/LOCKS/LINKAGES
2 complaints
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE REAR LIFT GATE DOOR COULD NOT BE OPENED WITH THE KEYLESS ENTRY FOB, MANUAL KEY OR BY USING THE LATCH MANUALLY. THE CONTACT HAD THE LATCH ASSEMBLY REPLACED HOWEVER, THE FAILURE RECURRED. THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 70,000. UPDATED 01/30/13*LJ UPDATED 1/31/2013 *JS
Dec 17, 2012
TL*THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHEN THE CONTACT ATTEMPTS TO LOCK HER VEHICLE WITH THE POWER LOCK FUNCTION, ALL THE DOORS LOCK EXCEPT THE REAR PASSENGER SLIDING DOOR. SHE HAS NOT TAKEN THE VEHICLE TO THE DEALER BECAUSE THEY WILL NOT PROVIDE HER WITH A RENTAL. THE FAILURE MILEAGE WAS 29,541 AND CURRENT MILEAGE WAS 30,000.
Nov 01, 2007
INTERIOR LIGHTING
2 complaints
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT WAS ENTERING THE VEHICLE WHEN THE DOME LIGHT FAILED TO ILLUMINATE. THE DEALER CONFIRMED THE DOME LIGHT SOCKET WAS MELTING AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 15,000 AND THE CURRENT MILEAGE WAS 78,000.
Nov 30, 2011
TL*THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE DOME LIGHTS IN HER VEHICLE STOPPED WORKING. THE DEALER ADVISED THE CONTACT THAT THEY DO NOT HAVE ANY REPLACEMENT BULBS. THE WIRING IN THE LIGHT EXHIBITS BURNS. THE DEALER HAS TO REPLACE THE BRACKET. THERE ARE NO RELATED RECALLS OR WARRANTIES ON THE PARTS. THE VEHICLE WILL BE REPAIRED BY THE DEALER WITHIN THE WEEK. THE FAILURE MILEAGE WAS 46,400.
Jan 08, 2010
VISIBILITY
2 complaints
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE DRIVER SIDE WINDOW FELL INTO THE DOOR PANEL ABNORMALLY. THE DEALER DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO WAS UNABLE TO DUPLICATE THE FAILURE AND ADVISED HER TO TAKE THE VEHICLE TO AN AUTHORIZED DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. NO REPAIRS WERE PERFORMED. THE CURRENT AND FAILURE MILEAGES WERE 72,000.
Oct 05, 2011
WHILE DRIVING THE REAR WINDOW BLEW OUT WITHOUT BEING HIT BY ANYTHING I REPLACED THE WINDOW AND WAS TOLD THIS WAS THE 2ND ONE THEY HEARD OF THIS WEEK ON A DODGE MINIVAN. *TR UPDATED 03/15/10 *BF UPDATED IVOQ 05/12/10
Jan 15, 2010
EQUIPMENT
2 complaints
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STARTED THE IGNITION AND THE AIR CONDITIONER FAILED TO OPERATE WHEN ACTIVATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT THE AIR CONDITIONER WAS LEAKING COOLANT. THE VEHICLE WAS NOT REPAIRED. THERE WAS A RECALL RELATED TO THE FAILURE ON THE 2008 DODGE GRAND CARAVAN. THE NHTSA CAMPAIGN ID NUMBER WAS 10V611000 (EQUIPMENT: ELECTRICAL: AIR CONDITIONER). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 85,000. THE VIN WAS UNAVAILABLE.
Aug 05, 2011
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THERE WAS A LEAK IN THE AIR CONDITIONER WHICH COULD CAUSE THE AIR BAG TO DEPLOY WITHOUT WARNING. THE DEALER NOR MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO INSERTED RED DYE WITH FREON THAT WOULD IDENTIFY AND PLUG THE LEAK. THE MECHANIC ADVISED THE CONTACT THAT THE REMEDY MAY OR MAY NOT CORRECT THE FAILURE. THE CURRENT MILEAGE WAS 83,000. THE APPROXIMATE FAILURE MILEAGE WAS 77,000.
Aug 04, 2011
SEAT BELTS
2 complaints
TL*THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE REAR PASSENGER SIDE SEAT BELT WOULD NOT OPERATE. SHE WAS CONCERNED BECAUSE THAT WAS THE LOCATION WHERE SHE LATCHED HER SMALL CHILD IN THE SAFETY SEAT. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE LESS THAN 38,000.
Apr 02, 2009
TL*THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHILE IDLING AT A RED LIGHT, A VEHICLE REAR ENDED THE CONTACT AND THE DRIVER SIDE REAR SEAT BELT DID NOT RETRACT. A POLICE REPORT WAS FILED. AS A RESULT, THE PASSENGER LUNGED FORWARD AND STRUCK HER FOREHEAD ON THE BACK OF THE DRIVER SEAT. THE DRIVER SUSTAINED MUSCLE AND BACK INJURIES. THE PASSENGER SUSTAINED FOREHEAD, NECK, AND EYE INJURIES. THE VEHICLE WAS INSPECTED BY THE DEALER AND THEY STATED THAT THE SEAT BELTS WORKED PROPERLY. THE VEHICLE SUSTAINED OVER $7,000 IN DAMAGES TO THE REAR END. THE VIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 9,385 AND FAILURE MILEAGE WAS 4,000.
Nov 05, 2007
TIRES
1 complaint
The contact owns a 2007 Dodge Grand Caravan equipped with Cooper Tires, Tire Line: Evolution Tour, Tire Size: 215/65/R16, DOT Number: (not available). The contact stated while driving 60 MPH, the driver’s side front tire experienced a blowout causing the steering wheel to shake. The contact was able to pull over safely and replace the tire. The failure reoccurred while driving however, the front passenger’s side the tire experienced the blowout. The dealer was contacted and stated that the tire was not under warranty. The manufacturer had been notified of the failure. The failure mileage was approximately 112,393.
Jul 07, 2022
STEERING,POWER TRAIN,SERVICE BRAKES
1 complaint
MY 2007 DODGE GRAND CARAVAN SE CAN BE EASILY SHIFTED INTO GEAR WHILE IN AUXILIARY POWER, AND IT SOMETIMES LOCKS OUT MY BRAKES, AS THERE IS A LOCKED STEERING WHEEL YOU CAN'T STEER IT AND CAN'T TURN IT ON WITHOUT SHIFTING BACK TO PARK WHICH CAN BE DIFFICULT IF THE BRAKES LOCK. A CHILD COULD EASILY SET IT IN GEAR IF YOU ARE RUNNING THE AIR AND YOU LEAVE THE CAR BRIEFLY, I DO NOT HAVE KIDS BUT I DO RUN SOME TAXI WORK IN THE NEIGHBORHOOD. IT COULD BE DONE ANYWHERE AS LONG AS IT'S IN AUXILIARY POWER TO RADIO AND ELECTRICS BUT NOT FULLY ON
Jan 07, 2020
ELECTRICAL SYSTEM,STRUCTURE
1 complaint
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHEN THE CONTACT ATTEMPTED TO LOCK THE VEHICLE WITH THE POWER LOCK FUNCTION, BOTH REAR SLIDING DOORS SEIZED WITHOUT WARNING AND WOULD NOT REOPEN. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 145,000.
Oct 10, 2019
VISIBILITY,STRUCTURE
1 complaint
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE VEHICLE REAR GLASS ABRUPTLY FRACTURED WHILE THE VEHICLE WAS PARKED AND UNOCCUPIED. THE CONTACT PURCHASED THE VEHICLE ON MARCH 28, 2018 AT (DON WOOD CHRYSLER, DODGE, JEEP, RAM 58 WEST SECOND STREET LOGAN, OHIO 43138 740-385-5626). THE VEHICLE WAS NOT TAKEN BACK TO THE DEALERSHIP FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 170,732. *TT
Mar 29, 2018
AIR BAGS,SEATS
1 complaint
ON OR ABOUT DECEMBER 2017, A 2007 DODGE GRAND CARAVAN WAS TRAVELING NB ON THE INTERSTATE AND WAS HIT FROM THE REAR BY A LARGER VEHICLE. BOTH THE DRIVER AND FRONT PASSENGER WERE WEARING THEIR SEAT BELTS AND TRAVELING 50-55 MPH. AFTER BEING IMPACTED FROM THE REAR, THE VEHICLE SPUN 360 DEGREES. AFTER THE SPIN, THE VAN WAS IMPACTED DIRECTLY HEAD ON, IN THE FRONT, ON THE PASSENGER SIDE, BY A 4 DOOR SEDAN. THE AIR BAGS FAILED TO DEPLOY AND BOTH THE DRIVER AND PASSENGER SEAT BELTS FAILED TO LOCK THE OCCUPANTS TO THEIR SEATS. THIS SAFETY EQUIPMENT FAILURE ALLOWED SIGNIFICANT BODY MOVEMENTS OF BOTH THE DRIVER AND PASSENGER. IT CAUSED ABRUPT FORWARD AND BACKWARD MOTION OF THEIR HEADS, NECKS, BACKS, ARMS, LEGS AND TORSOS, RESULTING IN SIGNIFICANT PHYSICAL INJURY AND EMOTIONAL TRAUMA. THE DRIVER ACCOMPANIED THE FRONT PASSENGER TO THE EMERGENCY ROOM. PHYSICAL EXAMINATION AND X-RAY EVALUATIONS WERE PERFORMED BY A MEDICAL SPECIALIST. THE PASSENGER WAS DIAGNOSED WITH UPPER SPINE, HEAD AND NECK INJURIES WITH SIGNIFICANT MUSCLE PAIN AND SEVERE CONCUSSION. THE DRIVER HAD INJURIES TO HIS SHOULDER, NECK, KNEE, TORSO AND BACK AREAS WITH SIGNIFICANT MUSCLE PAIN. SUMMARY, HAD THE SEAT BELTS FUNCTIONED, AS WAS ADVERTISED AND DESIGNED BY THIS MANUFACTURER, BOTH PASSENGERS WOULD NOT HAVE SUSTAINED SUCH SEVERE PHYSICAL INJURIES, AND HAD THE AIR BAGS FUNCTIONED AND DEPLOYED, AS ADVERTISED AND DESIGNED, BY THE MANUFACTURER, THE DRIVER AND PASSENGER WOULD NOT HAVE BEEN INJURED IN THIS IMPACT-COLLISION. HISTORY, THE DODGE GRAND CARAVAN OF PAST YEARS DESIGN INCLUDING THIS 2007 MODEL YEAR HAVE HAD SIMILAR AND REPEATED REPORTS OF SEAT BELT AND AIR BAG FAILURE. CONCLUSION, THIS MANUFACTURER KNEW OR SHOULD HAVE KNOWN OF THESE SAFETY DEFEATS, FROM PAST SETTLEMENT LITIGATION. THIS MANUFACTURER ALLEGEDLY HAS FAILED OR REFUSED TO CORRECT THESE ALLEGED INJURY CAUSING VEHICLE SEAT BELT AND AIR BAG DEFECTS.
Dec 25, 2017
POWER TRAIN,STRUCTURE
1 complaint
THE VEHICLE WAS PARKED ON AN INCLINED DRIVEWAY. THE VEHICLE WAS TURNED OF AND THE KEY WAS NOT IN THE IGNITION. MY DAUGHTER PULLED THE COLUMN SHIFTER WITHOUT PRESSING THE BRAKE PEDAL. THE VEHICLE SHIFTED INTO REVERSE AND ROLLED BACKWARDS DOWN THE DRIVEWAY. THE FRONT PASSENGER SIDE DOOR WAS OPEN. THE DOOR STRUCK A TREE AND STOPPED THE ROLLING VEHICLE.
Mar 12, 2016
STEERING,FUEL/PROPULSION SYSTEM
1 complaint
AFTER FILLING UP THE TANK WITH GAS, THE CAR, ALMOST ALWAYS, STALLS, A FEW MINUTES INTO DRIVING. I'VE BEEN CONCERNED ABOUT THIS, SINCE MY WIFE MOSTLY USES THIS CAR, AND HAS STALLED ON THE HIGHWAY SEVERAL TIMES.I HAVE HAD IT STALL IN THE MIDDLE OF A BUSY INTERSECTION.OF COURSE, THE POWER STEERING ALSO CUTS OUT WHEN THE ENGINE SHUTS DOWN WHICH COMPOUNDS THE DANGER. WHEN I "GOOGLED" THE WORDS "2007 GRAND CARAVAN STALLS", A VERY LONG LIST OF PEOPLE WITH THE SAME COMPLAINT IMMEDIATELY CAME UP.APPARENTLY, THE SMALL PART CAUSING THIS MALFUNCTION IS PART OF THE ENTIRE GAS TANK AND CANNOT BE REPLACED WITHOUT REPLACING THE ENTIRE GAS TANK. THIS IS A VERY EXPENSIVE REPAIR, AND NOT AFFORDABLE TO MANY. CHRYSLER SHOULD BE RECALLING THESE VEHICLES AND REPAIRING WHAT IS OBVIOUSLY A MAJOR DESIGN FLAW, BEFORE SOMEONE IS SERIOUSLY HURT OR KILLED. THIS IS NOT A DEFECT IN SOME INNOCUOUS INTERIOR PART OF THE CAR, IT AFFECTS THE SAFE OPERATION OF A MOVING VEHICLE!
Feb 05, 2016
EXTERIOR LIGHTING,STRUCTURE,FUEL/PROPULSION SYSTEM
1 complaint
ENGINE STALLS POST REFUELING WHILE VEHICLE IN MOTION IN PARKING LOT AND ON ROADWAY INTERIOR READING LIGHTS MELTING AND SMOKING WHEN TURNED ON DOOR LOCK ON RIGHT AND LEFT REAR SLIDING DOOR WILL NOT LOCK OR UNLOCK VIA AUTO DOOR LOCKING/ UNLOCKING BUTTON.
Dec 26, 2015
POWER TRAIN,ELECTRICAL SYSTEM,ENGINE
1 complaint
1ST OCCURRENCE: WHILE DRIVING ON FREEWAY ON A HOT DAY THE CAR STALLED WITHOUT WARNING. ON ATTEMPTED RESTARTS CAR WOULD FIRE FOR A COUPLE OF SECONDS AND QUIT. TRIED OTHER KEY: NO HELP. AFTER ABOUT 7 OR 8 ATTEMPTS THE CAR WOULD NOT CRANK AND SOLENOID CLICKED. TOWED HOME. CAR SET CODES P0339 AND P0344(INTERMITTENT CRANK AND CAM SENSOR). CHARGED BATTERY . REPLACED BOTH SENSORS CAR INITIALLY WOULD NOT START, THEN MYSTERIOUSLY FIRED UP AND RAN FINE. OK FOR ABOUT A MONTH. BATTERY TESTED OK CHARGING VOLTAGE GOOD WHEN RUNNING. NOT RELATED TO HAVING JUST (OVER)FILLED GAS TANK. (MUCH ON INTERNET ABOUT THIS: BAD VALVE IN TANK ALLOWS EVAP TO FLOOD) 2ND OCCURRENCE. ONCE AGAIN DRIVING ON HIGHWAY HOT DAY. ONCE AGAIN STALLED WITHOUT WARNING. SAME SYMPTOMS ON ATTEMPTED RESTART. AFTER WAITING ABOUT 15 MINUTES, CAR RESTARTED, RAN ABOUT 4 MILES AND STALLED AGAIN. ATTEMPTED FOUR OR FIVE RESTARTS, THEN BATTERY APPEARED TO RUN DOWN. HEADLIGHTS WOULD DIM ON START ATTEMPT. AFTER A WHILE THE CAR STARTED AGAIN BUT RAN ROUGHLY ON ACCELERATION. ONCE AGAIN SET SAME CODES. AT THIS POINT I NOTICED SOME ELECTRICAL ANOMALIES. UPON KEY ON, THE TEMP, FUEL, AND TACH GAUGES WOULD PEG HIGH AND THEN FALL BACK TO NORMAL. THE POWER WINDOWS BEGAN TO OPERATE WITHOUT THE KEY ON. TOW TRUCK ARRIVED AND GOT IT HOME. CAR RESTARTED IN GARAGE. REPLACED BOTH SENSORS AGAIN AND BATTERY (SUSPECTED INTERMITTENT OPEN). 3RD OCCURRENCE ON TEST DRIVE GOT ABOUT 5 MILES AND ONTO HIGHWAY. ONCE AGAIN STALLED. THIS TIME RESTARTED, TURNED AROUND AND GOT ABOUT 2 MILES THEN QUIT AGAIN. THIS TIME NO RESTART( SAME 2-3 SECONDS). THIS TIME SET CODE P0344 ONLY(CAM SENSOR INTERMITTENT). CAR RESTARTED LATER BACK IN SHOP. RESEARCH ON THE INTERNET HAS GOT ME THINKING ABOUT THE TIPM (TOTALLY INTEGRATED POWER MODULE)
Aug 14, 2015
ELECTRICAL SYSTEM,STRUCTURE,SEATS
1 complaint
2007 DODGE GRAND CARAVAN SXT STOW N GO HAVING SEVERAL ELECTRICAL ISSUES. 1. PASSENGER POWER SLIDING DOOR FAILED, REPLACED POWER DOOR MOTOR, LOCK ACTUATOR, AND REPAIRED WIRING AS THE WIRES ACTUALLY BREAK/SNAP OVERTIME. POOR DESIGN. 2. LESS THAN TWO YEARS LATER PASSENGER POWER SLIDING DOOR HAS FAILED AGAIN, & POWER LOCKS WILL NOT WORK, & I CAN OPEN PASSENGER SLIDING DOOR AFTER LOCKING VEHICLE WITH KEY FOB AND ALARM WON'T SOUND! CANNOT GET MY CHILDREN IN AND OUT OF THIS DOOR WITHOUT REACHING IN AND PULLING UP THE LEVER FROM INSIDE (TOO STIFF, MY DAUGHTER ISN'T STRONG ENOUGH). THIS IS A SAFETY ISSUE AND RESEARCHING IT ONLINE SHOWS THAT IT IS WIDESPREAD. 3. POWER SEAT MOTOR HAS FAILED. WE HAVE STOW N GO SEATING. IN ORDER TO STOW THE 2ND ROW SEAT YOU MUST MOVE FRONT SEAT TO FULL FORWARD POSITION, THEN MOVE DRIVER SEAT BACK......DRIVER SEAT IS ALL THE WAY BACK NOW (FOR MY SPOUSE) AND I CANNOT MOVE IT FORWARD. GEARS ARE BROKEN. I CANNOT REACH THE PEDALS AND MY SEVENTH SEAT IS STOWED! I CANNOT GET MY SEAT BACK. 4. ON PASSENGER SIDE A PART BELOW DASHBOARD (I THINK IS RELATED TO HEATING AND COOLING) FELL OFF. MY FLOOR IS NOW WET EVEN AFTER REATTACHING IT. 5. LIGHT GALORE! MY VEHICLE ROTATES BETWEEN CHECK ENGINE, AND SERVICE TIRE SYSTEM WARNINGS. I'VE HAD IT CHECKED BY SEVERAL MECHANICS AND ALL SAY IT'S ELECTRICAL. *TR
Dec 26, 2014
VEHICLE SPEED CONTROL,FUEL/PROPULSION SYSTEM
1 complaint
MY WIFE JUST FINISHED REFUELING AND PROCEEDED FROM THE STATION AND TURNED OUT ON THE HIGHWAY. UPON APPROACHING A STOPLIGHT CAME TO A COMPLETE STOP. AFTER THE LIGHT TURNED GREED PROCEEDED TO ACCELERATE, AFTER PRESSING THE ACCELERATOR THE VEHICLE BEGAN TO STUMBLE AND THEN STALL. *TR
Nov 09, 2014
ENGINE AND ENGINE COOLING,FUEL/PROPULSION SYSTEM
1 complaint
AFTER FUELING THE VEHICLE, PULLING OUT FROM THE GAS STATION, THE VAN STALLS VIOLENTLY: LOSES POWER, LURCHES & SURGES. THIS HAS BECOME INCREASINGLY SEVERE, MOST RECENTLY NEARLY CAUSING A COLLISION WHEN THE VAN STALLED OUT AS WE WERE LEAVING THE GAS STATION IN HEAVY TRAFFIC. THE PROBLEM IS THE VAPOR/LIQUID SEPARATOR VALVE LOCATED AT THE TOP OF THE FUEL TANK. THE VALVE IS DESIGNED TO PREVENT LIQUID FUEL FROM ENTERING THE CHARCOAL CANISTER/EMISSIONS SYSTEM. WHEN THE VALVE FAILS, LIQUID GAS CAN ENTER THE LINE AND FILL THE CHARCOAL CANISTER. AFTER REFUELING THE PCM ON THE VEHICLE DETECTS A CHANGE IN FUEL LEVEL. THEN, WHEN THE ENGINE MEETS CERTAIN TEMPERATURE AND DRIVING CRITERIA, THE PCM ISSUES A PURGE COMMAND TO THE CHARCOAL CANISTER TO REMOVE THE STORED GAS VAPORS. IT?S AT THAT POINT THAT ALL THE LIQUID GAS IN THE LINE GETS SUCKED INTO THE CHARCOAL CANISTER. THE PCM EXPECTS TO SEE GAS VAPORS ENTERING THE INTAKE MANIFOLD AND IT IS PREPARED TO ADJUST AIR/FUEL MIXTURES TO COMPENSATE. HOWEVER, IT IS NOT PREPARED TO SEE LIQUID GAS COMING INTO THE INTAKE. THAT?S WHAT CAUSES THE ENGINE TO STALL. UNFORTUNATELY, THE ONLY FIX IS TO REPLACE THE ENTIRE GAS TANK. CHRYSLER DOES NOT SELL THE VAPOR/LIQUID VALVE AS A SEPARATE UNIT. WE ARE NOW AT NEARLY 100,000 MILES, AND THE PROBLEM PERSISTS AND CONTINUES TO GET MORE SEVERE. I HAVE CALLED DODGE, BUT THEY SAY THERE IS NO EXTENDED WARRANTY ON THE FUEL TANK/EVAPORATION CANISTER. *TR
Sep 25, 2014
STEERING,ELECTRICAL SYSTEM,ENGINE
1 complaint
ON THREE SEPARATE OCCASIONS WHEN DRIVING THE CAR, THE IGNITION KEY SUDDENLY SHUT OFF THE ENGINE CAUSING DIFFICULTY WITH STEERING AS WELL. THIS WAS CHECKED BY THE DEALERSHIP WHO COULD FIND NO REASON FOR THE ACTION. *TR
Jul 01, 2014
EXTERIOR LIGHTING,INTERIOR LIGHTING
1 complaint
JUST BOUGHT A 2007 DODGE GRAND CARAVAN AND REALIZED THE FRONT READING LIGHTS WERE NOT WORKING. I TOOK OF THE PLASTIC COVERS IN AN ATTEMPT TO CHANGE THEM AND OBSERVED THAT THE BULB HAD COMPLETELY MELTED THE PLASTIC AND BURNT PART OF THE CASING. IT APPEARS AS THOUGH THE PLASTIC HOUSING WAS VERY CLOSE TO, OR HAD ALREADY, CAUGHT ON FIRE. I AM WORRIED THAT IF WE PUT A NEW LIGHT BULB IN THE SAME HOUSING IT WILL LIKELY CATCH THE WHOLE VAN ON FIRE. THE SAFETY OF MY FAMILY BEING PARAMOUNT, I DO NOT FEEL SAFE DOING SO. AFTER REVIEWING THIS PROBLEM ONLINE, I FOUND NUMEROUS OTHER GRAND CARAVAN OWNERS CLAIMING TO HAVE HAD THE SAME PROBLEM. THIS ISSUE NEEDS TO BE FIXED BEFORE SOMEONE GETS HURT, OR EVEN WORSE, KILLED. *TR
Mar 11, 2014
POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM
1 complaint
I JUST COMPLETED FILLING UP MY VEHICLE WITH REGULAR GASOLINE. ABOUT 100 YARDS FROM THE FILLING STATION, MY VAN STUTTERED AND STALLED. IT DOES THIS EVERY TIME I FILL IT UP. IT STALLED IN THE MIDDLE OF AN INTERSECTION. I DID SOME RESEARCH AND IT LOOKS LIKE IT IS THE RESULT OF A FAILED COMPONENT OF THE EMISSIONS SYSTEM AND A PRETTY COMMON PROBLEM WITH CHRYSLER/DODGE VANS. HTTP://COMMUNITY.CARTALK.COM/DISCUSSION/2137227/ENGINE-DIES-AFTER-GASOLINE-FILL-UP. *TR
Dec 21, 2013
STRUCTURE,SEATS
1 complaint
WE WERE STOPPED BEHIND AN AMBULANCE IN TRAFFIC WHEN A LARGE PICK-UP TRUCK BARRELED INTO US. DRIVER WAS INTOXICATED. MY 5-YEAR OLD DAUGHTER WAS STRAPPED INTO THE BUILT-IN BOOSTER SEAT IN THE MIDDLE BENCH. ON IMPACT, THE WHOLE BENCH CAME OUT OF THE FLOOR AND FLIPPED HER FORWARD AND THEN BACKWARDS. SHE SUSTAINED A BLACK EYE. *TR
Dec 03, 2012
VISIBILITY,VISIBILITY/WIPER
1 complaint
REAR WINDOW SHATTERED WHILE PARKED OVERNIGHT IN A LOCKED GARAGE. NO IMPACT, TEMPERATURE ABOVE FREEZING. *TR
Nov 10, 2012
ELECTRICAL SYSTEM,EXTERIOR LIGHTING,ENGINE
1 complaint
INTERIOR DOME LIGHTS STOPPED WORKING. NOW, THE "MALFUNCTION LIGHT" IS LIT UP ON THE DASHBOARD AT 38,000 MILES. *TR
Jun 28, 2012
ELECTRICAL SYSTEM,INTERIOR LIGHTING,EQUIPMENT,ENGINE
1 complaint
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT ATTEMPTED TO START THE IGNITION THREE TIMES AND THE ENGINE IMMEDIATELY STALLED. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE VEHICLE CONTINUED TO REMAIN AT THE DEALER FOR FURTHER INVESTIGATION WHERE THE CONTACT WAS AWAITING A DIAGNOSIS OF THE FAILURE. THE MANUFACTURER WAS ALSO NOTIFIED OF THE PROBLEM. IN ADDITION, THE WIRING TO THE DOME LIGHT WAS FAULTY WHICH CAUSED THE DOME LIGHT TO MELT TWO YEARS PRIOR TO THE MOST RECENT FAILURE. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 50,000. ....UPDATED 08-24-12 *BF THE CONSUMER STATED WHEN THE VEHICLE'S ENGINE TURNED OFF THE INSTRUMENT CLUSTER REMAINED ILLUMINATED. THE RADIO SWITCHES STATIONS, TURNS ON THE CD PLAYER, AND SWITCHES BETWEEN AM/FM. THE DEALERSHIP ACKNOWLEDGED THERE IS AN ELECTRICAL PROBLEM BUT, CANNOT FIND THE PROBLEM. UPDATED 08/30/2012 *JS
Jun 19, 2012
ENGINE AND ENGINE COOLING,POWER TRAIN,VEHICLE SPEED CONTROL
1 complaint
FOUR SEPARATE INSTANCES OF AN UNINTENDED ACCELERATION OCCURRED WITHIN 5 MINUTES WHILE TRAVELING AT LOW SPEEDS (5 - 15 MPH). EACH OF THESE INSTANCES IS DESCRIBED BELOW: 1. WHILE TURNING RIGHT OUT OF A GAS STATION AT ABOUT 5-10 MPH, THE CAR LURCHED FORWARD AND THE POWER STEERING SYSTEM SEEMED TO FAIL (I.E., THE CAR WAS STEERING RIGHT AND IT WAS VERY DIFFICULT TO KEEP FROM CONTINUING RIGHT INTO A CURB). THE BRAKES WORKED FINE AND PREVENTED A COLLISION WITH THE CURB. I HEADED FOR A FRIEND'S HOUSE LOCATED NEARBY. 2. APPROXIMATELY 500 - 1000 FEET LATER, WHILE TURNING LEFT AT 15 MPH ONTO A SIDE STREET, THERE WAS ANOTHER UNINTENDED ACCELERATION AND THE STEERING WHEEL WAS 'LOCKED' LEFT (I.E., THE POWER STEERING SYSTEM AGAIN SEEMED TO FAIL). THE BRAKES ON AND THE CAR COLLIDED WITH THE CURB AT A LOW SPEED (1-3 MPH). HAD TRAFFIC BEEN COMING DOWN THE ROAD, A CAR HEADING TOWARD ME WOULD HAVE HIT THE SIDE OF MY CAR. 3. APPROXIMATELY 500 FEET DOWN THAT STREET, WHILE TURNING LEFT ONTO ANOTHER SIDE STREET, THE ENGINE REVVED AGAIN FOR A SECOND, AND RETURNED TO NORMAL. THE STEERING AND BRAKES WERE NOT ADVERSELY AFFECTED. 4. I PROCEEDED SLOWLY DOWN THAT STREET FOR A DISTANCE OF ABOUT 200 FEET AND WAS SLOWING DOWN TO PARK ALONG THE RIGHT HAND SIDE OF THE STREET. WHILE GOING ONLY ABOUT 2 MPH, THE CAR REVVED HARD AGAIN, AND LURCHED FORWARD ABOUT 3 FEET UNTIL I COULD STOP THE CAR. I STAYED AT THE FRIEND'S HOUSE FOR 3 HOURS. 5. A SERVICE STATION WAS NEARBY AND I DROVE SLOWLY TOWARD IT. THE CAR MADE A TOTAL OF 3 RIGHT TURNS AND 2 LEFT TURNS WITHOUT INCIDENT. HOWEVER, WHEN JUST STARTING TO MAKE A 4TH RIGHT TURN, THE ENGINE REVVED AND THE POWER STEERING SEEMED TO FAIL AGAIN. I STOPPED THE CAR AND TURNED OFF THE IGNITION. I PROCEEDED A HALF MILE TO THE REPAIR STATION (WITH 3 LEFT TURNS AND 1 RIGHT TURN), WITHOUT INCIDENT. *TR
Feb 13, 2012
STEERING,SERVICE BRAKES, HYDRAULIC
1 complaint
2007 DODGE GRAND CARAVAN. CONSUMER WRITES IN REGARDS TO PROBLEM WITH TIE RODS *TGW ALSO, THE ABS SENSOR WAS REPLACED. *JB
Sep 29, 2011
SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM
1 complaint
I TURNED THE IGNITION ON, PUT THE CAR IN REVERSE AND BACKED OUT OF A PARKING SPACE. I PUSHED ON THE BRAKES AND PUT THE CAR IN DRIVE. THE CAR BEGAN MOVING FORWARD FOR ABOUT 10 SECONDS AND THEN IT LOST ALL POWER WITH NO WARNING, JUST STALLED. THE CAR'S HEAT SENSOR GAUGE WAS NORMAL JUST BELOW HALFWAY AND I HAD A HALF TANK OF GAS. THERE WERE NO WARNING LIGHTS ON THE DASHBOARD PRIOR TO THE INCIDENT. IT DIDN'T FEEL LIKE THE BRAKES WERE WORKING EITHER. I PUT THE CAR IN PARK AND THEN STARTED IT UP AGAIN WITH NO PROBLEMS. IT DROVE TO MY DESTINATION WITHOUT ANY FURTHER PROBLEMS.
Jul 25, 2011
SERVICE BRAKES, HYDRAULIC
1 complaint
AROUND JANUARY 2011, I NOTICED A RUBBING NOISE AFTER BEING PART OF A FUNERAL PRECESSION. THE NOISE WOULD COME AND GO. THERE WERE ALSO A LITTLE SHAKING LIKE A POTHOLE WHEN NOTHING WAS THERE AND I ASSUMED IT WAS THE ROAD BUT I COULDN'T SEE IT. I WAS NOT COMFORTABLE WITH THE NOISE AND NEEDED TO TRAVEL SO I TOOK IT A SHOP. ON FEBRUARY 23RD I WAS TOLD I HAD A LOW LEVEL BRAKE PAD AND TO RETURN IN 6 TO 8 WEEKS. MY FRONT BRAKES WERE DONE AT 40,000 MILES AND THE REAR WERE DONE OCTOBER 2010. THE VEHICLE WAS NEAR 60,000 MILES ON THIS CHECK-UP. I WAS STILL NOT COMFORTABLE AND WAS GOING TO RETURN IN EARLY MARCH, WHEN I GOT PAID. I WENT TO APPLY MY BRAKES GOING TO WORK...THEY DIDN'T WORK CORRECTLY...I HIT TWO CARS (TOTALED MY CAR AND MIDDLE CAR). MY BRAKES FAILED AT OVER 60,000. MY LOWER LEGS STILL HURT OVER 2 MONTHS AFTER THE AIRBAGS DEPLOYED. *TR
May 15, 2011
SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING,EQUIPMENT
1 complaint
I BROUGHT MY 2007 DODGE GRAND CARAVAN TO A DEALERSHIP FOR AN INSPECTION. FRONT AND REAR BRAKES WERE REPLACED AND AN EGR VALVE WAS REPLACED IN ORDER FOR IT TO PASS INSPECTION. BEFORE THE REPAIRS WERE DONE I WAS GETTING APPROXIMATELY 20 MILES TO THE GALLON. THIS ALSO SHOWED UP ON THE INTERIOR ELECTRONIC INFORMATION CENTER. AFTER THE REPAIRS WERE DONE, MY INTERIOR ELECTRONIC INFO CENTER INDICATED I WAS GETTING APPROXIMATELY 10 MILES TO THE GALLON. I CONFIRMED THIS BY THE "OLD FASHION WAY" OF FILLING THE TANK AND DRIVING THEN FILLING IT AGAIN AND DIVIDING THE MILES BY THE NUMBER OF GALLONS. THIS CONFIRMED THAT I WAS GETTING APROX 10 MILES PER GALLON. I CALLED THE DEALERSHIP AND TO THIS DATE HAVE HAD NO RESPONSE. I'M ALSO CONTINUING TO KEEP TRACK OF THE MILEAGE AND AMOUNT OF FUEL I'M USING. THE SAME THING HAPPENED WITH MY WIFE'S DODGE JOURNEY. THE WEB SITE, WWW.FUELECONOMY.GOV SHOWS THAT I SHOULD BE GETTING APROX 20 MILES PER GALLON EVEN WITH THE NEW 10% ALCOHOL ADDITION AND THESE WERE THE APROX EPA STANDARDS WHEN THE VEHICLE WAS SOLD. I AM CONTINUING MY RESEARCH IN THIS MATTER TO BRING IT TO MY SATISFACTION. *TR
Feb 24, 2011
ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE
1 complaint
2007 DODGE GRAND CARAVAN DIES AFTER FILLING UP WITH GAS CREATING A DRIVING HAZARD AND A DANGEROUS SITUATION, THIS HAPPENS NOW WITH EVERY FILL UP, DIDN'T HAPPEN UNTIL NOV. 2010, NOW IT HAPPENS CONSISTENTLY WITH EVERY FILL UP. *TR
Jan 20, 2011
ELECTRICAL SYSTEM,AIR BAGS,UNKNOWN OR OTHER
1 complaint
AIR BAG LIGHT CAME ON AND WILL NOT GO OFF. PER OWNERS MANUAL AND OTHER SOURCES - THIS IS A FAILURE OF THE AIRBAG SENSOR. CAUSE IS LEAKAGE INTO THE SENSOR FROM ROAD SALT AND OR WATER. AIR BAG IS POSSIBLY IN A NON-WORKING CONDITION - THUS LEAVING THE POTENTIAL FOR BODILY HARM IF A CRASH SHOULD OCCUR. MANUFACTURER IS NOT OFFERING A FIX AT THIS TIME, AND ACTUALLY DENIES ANY PROBLEMS WITH SAID DEVICES.
Nov 28, 2010
SEAT BELTS,EQUIPMENT
1 complaint
I HAVE A 2007 DODGE GRAND CARAVAN THAT HAS IT'S MIDDLE ROW RIGHT SEATBELT REPLACED TWICE IN LESS THAN TWO YEARS. FIRST ONE FEB. 2009 AND SECOND ONE NOV. 2010. SAME PROBLEM EACH TIME WITH THE SEATBELTS - THEY WOULD JUST QUIT WORKING - THEY WOULD GET STUCK AND WOULD NOT BE ABLE TO LATCH SEATBELT. AND IF YOU COULD GET IT LATCHED FOR SOME REASON - IT WOULD BE NEARLY IMPOSSIBLE TO GET IT UNLATCHED WHEN NEED TOO. *TR
Nov 08, 2010
STEERING,SERVICE BRAKES, AIR
1 complaint
OUR 2007 DODGE GRAND CARAVAN SXT SHOWS PREMATURE WEAR IN THE BRAKE AND RACK-AND-PINION SYSTEMS. THE FRONT BRAKE PADS HAD TO BE REPLACED AT 20,500 MILES AND AGAIN AT 42,300 MILES. THE BRAKE PADS WERE COMPLETELY WORN OUT AFTER JUST ABOUT 20,000 MILES TWICE NOW. THIS IS A SAFETY CONCERN, BECAUSE YOU DO NOT EXPECT THE BRAKES TO WEAR OUT AFTER 20,000 MILES PARTICULARLY IN THIS FAMILY CAR, ALWAYS DRIVEN WITH KIDS, VERY CAUTIOUSLY AND NEVER OFF-ROAD. THE RACK-AND-PINION SYSTEM IS WORN OUT AT 42,300 MILES AND THAT IS ALSO A SAFETY CONCERN BECAUSE IT IS PREMATURE AS WELL. THE CONSUMER DOES NOT EXPECT A FAILURE AFTER SUCH FEW MILES. THE CAR HAS BEEN REGULARLY AND METICULOUSLY INSPECTED AT THE CHRYSLER DODGE DEALERSHIP ACCORDING TO DODGE SPECIFICATIONS WHERE WE BOUGHT THE CAR AT 11,234 MILES IN MAY 2008. *TR
Aug 22, 2010
TRACTION CONTROL SYSTEM
1 complaint
ABS FAILURE. ABS HARNESS NEEDED REPLACED. *TR
Jul 23, 2010
VEHICLE SPEED CONTROL,INTERIOR LIGHTING
1 complaint
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE REPLACING A LIGHT BULB IN THE OVERHEARD CONSOLE, HE NOTICED THE BULB HOLDING UNIT WAS DETERIORATING. HE STATED THE FAILURE APPEARED TO HAVE BEEN CAUSED BY THE BULB OVERHEATING AND CAUSING DAMAGE TO THE UNIT. THE DEALER ADVISED THE MANUFACTURER WAS AWARE OF THE FAILURE AND A NEWLY DESIGNED UNIT WAS AVAILABLE BUT ONLY AT THE OWNERS EXPENSE. IN ADDITION, THE CONTACT STATED THE ACCELERATOR PEDAL WOULD INTERMITTENTLY BECOME STUCK IN THE OPEN THROTTLE POSITION. THE VEHICLE WAS NOT REPAIRED AND THE FAILURE PERSISTED. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 82,000.
May 27, 2010
SERVICE BRAKES, HYDRAULIC,AIR BAGS
1 complaint
2007 DODGE GRAND CARAVAN. SINCE ABOUT 5,000 MILES THE VAN HAS HAD AN INTERMITTENT RUMBLING/SQUEALING FROM THE BRAKING SYSTEM, MORE PRONOUNCED AT A STOP, BUT ALSO AT LOW TO MID-SPEEDS. THIS PAST WEEKEND, WHILE DRIVING DOWN THE DRIVEWAY AT LESS THAN 10 MPH, THE ABS RUMBLED SO LOUD THE ENTIRE VAN SHOOK. WE THEN STOPPED THE VAN, PLACED IT IN PARK AND THEN BACK INTO GEAR (DRIVE). WHEN THE BRAKES WERE AGAIN APPLIED, THEY WERE ROCK SOLID (NO MOVEMENT OF THE BRAKE PEDAL) THEN THE PEDAL WENT ALL THE WAY TO THE FLOOR, RESULTING IN A COLLISION WITH A TREE VICE AN ON-COMING VEHICLE. THE PASSENGER FRONT TIRE ROLLED SLIGHTLY UP THE TREE, BROKE THE WHEEL FRAME CONNECTION PIECE, BENT THE SWAY ARM, BUCKLED THE FRONT QUARTER PANEL, AND EXPLODED THE TIRE. VAN CURRENTLY HAS 16K MILES. NO INJURIES. EVENT WAS WITNESSED BY THREE PEOPLE OUTSIDE OF THE VEHICLE. BUT WITH THAT TYPE OF HIT ON THE TREE, SHOULDN'T THE AIRBAGS HAVE ALSO DEPLOYED? *TR
May 26, 2009
SUSPENSION
1 complaint
VEHICLE FAILED STATE SAFETY INSPECTION AT 38K MILES. 2 INDEPENDENT MECHANICS FELT IT ESPECIALLY DANGEROUS TO CONTINUE DRIVING VEHICLE. TIE-RODS REPLACED (BUT NOT SAVED). *TR
Feb 09, 2009
POWER TRAIN,EXTERIOR LIGHTING,STRUCTURE,LATCHES/LOCKS/LINKAGES,ELECTRICAL SYSTEM
1 complaint
TL*THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. FROM SEPTEMBER OF 2007 UNTIL MAY OF 2008, THE VEHICLE WAS TAKEN TO THE DEALER THREE TIMES FOR TRANSMISSION FAILURE. WHILE ATTEMPTING TO ACCELERATE FROM A RED LIGHT, THE TRANSMISSION FEELS AS IF IT WILL DROP TO THE GROUND WHEN SHIFTING FROM FIRST TO SECOND GEAR. ON MAY 14, 2008, THE TRANSMISSION WAS FINALLY REPAIRED UNDER WARRANTY. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION BECAUSE PAINT WAS PEELING FROM THE REAR PASSENGER SIDE QUARTER PANEL. THE DEALER STATED THAT TAR ADHERED TO THE PAINT; THEREFORE, THEY WASHED THE QUARTER PANEL AND SCRAPED OFF THE PAINT. WHEN THE VEHICLE AND HEADLIGHTS ARE TURNED OFF, THE INSTRUMENT PANEL LIGHTS, FOG LIGHTS, AND HEADLIGHTS WOULD REMAIN ILLUMINATED, EVEN THOUGH THE SWITCH WAS IN THE OFF POSITION. WHILE THE VEHICLE WAS PARKED, THE EXTERIOR LIGHTS WOULD ILLUMINATE AUTOMATICALLY, WHICH DRAINED THE BATTERY. THE DEALER STATED THAT THE HEADLAMP SWITCH SHORTED OUT. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE CONTACT STATED THAT THE SWITCH ON THE PANEL TO SHUT THE VEHICLE DOORS DID NOT WORK FOR TWO DAYS. IT HAS BEGUN TO WORK AGAIN, BUT THE CONTACT BELIEVES IT IS ONLY A MATTER OF TIME BEFORE THE SWITCH FAILS AGAIN. THE CURRENT MILEAGE WAS 7,000 AND FAILURE MILEAGE WAS 2,500. UPDATED 07/10/08. *LJ UPDATED
Jun 11, 2008
POWER TRAIN,EQUIPMENT
1 complaint
SINCE MIDDLE OF LAST DECEMBER 2007 I CANNOT USE MY CAR BECAUSE ?TRANSMISSION HAS NO REVERSE?. THIS IS SECOND TIME A TROUBLE LIKE THIS HAPPENS. FIRST TIME IT HAPPENED ON LAST OCTOBER 2007 AT 2,230 MILES. ). I CANNOT AGREE WITH YOUR CORPORATION'S DECISION AND LARRY MILLER DODGE SERVICE CENTER'S DECISION TO REPAIR THE VAN AT EVERY 2,000 MILES. PLEASE HELP ME. *TR
Feb 26, 2008
ELECTRICAL SYSTEM,EXTERIOR LIGHTING,INTERIOR LIGHTING
1 complaint
WHEN SLOWING DOWN AFTER DRIVING IN OVERDRIVE AND PRIOR TO ENGINE REACHING NORMAL OPERATING TEMPERATURE ALL LIGHTS (HEAD, TAIL, DASH, DOME, ETC) DIM TO A NEARLY OFF BRIGHTNESS AND COME RIGHT BACK TO NORMAL BRIGHTNESS AT THE 3/2 DOWN SHIFT. THIS HAS OCCURRED SINCE THE VEHICLE WAS NEW AND THE DEALER ADVISES THAT EVERYTHING IS WORKING AS DESIGNED. I DON'T THINK CHRYSLER DESIGNED THE LIGHTS TO FLASH OFF AND ON WHEN SLOWING DOWN. ALSO, AT 7 MONTHS (15696 MILES) THE BATTERY FAILED AND HAD TO BE REPLACED. *TR
Feb 13, 2008
STEERING,ELECTRICAL SYSTEM
1 complaint
ON 8/22/07 I PURCHASED A 2007 DODGE GRAND CARAVAN FROM ED NAPLETON DODGE IN OAKLAWN, ILLINOIS. ON 10/5/07 WHILE DRIVING MY VEHICLE, IT OVERHEATED AND THE STEERING WENT OUT OF CONTROL CAUSING THE VEHICLE TO BE HARD TO STEER. LOOKING UNDER THE HOOD THE ALTERNATOR BELT WAS IN SHREDS. IT WAS LEARNED THAT THE POWER STEERING PUMP WENT OUT. *JB
Oct 09, 2007
POWER TRAIN,ELECTRICAL SYSTEM,LATCHES/LOCKS/LINKAGES
1 complaint
WE PURCHASED AN 07' DODGE GRAND CARAVAN JUNE 07 AND HAVE HAD NOTHING BUT PROBLEMS W/ IT SINCE SHORTLY AFTER THE PURCHASE. IT HAS BEEN IN THE SHOP TWICE FOR THE SAME ISSUE AND IS CONTINUING TO HAVE THE PROBLEM. WHEN WE HAD IT IN THE LAST TIME WE WERE TOLD CHRYSLER WAS WORKING ON THE PROBLEM AND WOULD HAVE SOMETHING DURING THE MONTH OF AUGUST ... WELL I PHONED SEPT 11 12:15 PM AND WAS TOLD AT THAT TIME THEY STILL HAD HEARD NOTHING IN REGARDS TO THE ISSUE. IT STARTED OUT THAT THE VAN WOULD NOT SHIFT INTO GEAR WHEN COMING TO A STOP ... FEELS LIKE THE TRANSMISSION IS GOING TO DROP OUT AT TIMES. IT THEN MOVED TO DOING THIS WHILE IN MOTION AS WELL ... THE DEALER ASSURED US THAT NOTHING IS GOING TO HAPPEN IT IS A COMPUTER PROBLEM THAT CHRYSLER IS WORKING ON. THERE ARE OTHER KNOWN CUSTOMERS W/ THE SAME PROBLEM. WHEN WE HAD IT IN THE SHOP THE FIRST TIME A DX WAS RAN ON THE COMPUTER TO RESET EVERYTHING ... DIDN'T HELP AT ALL. HAD IT BACK IN A WEEK LATER FOR 9+DAYS AND AT THAT TIME THEY DROPPED THE TRANSMISSION OUT AND REPLACED THE CLUTCHES AND SOMETHING ELSE TOO. AS SOON AS WE DROVE IT OFF THE LOT IT WAS BACK TO SQUARE ONE. MY KEY HAS GOTTEN STUCK IN THE IGNITION ONCE SO FAR ... DIDN'T TAKE IT IN BUT DID PHONE TO LET THEM KNOW ABOUT THE ISSUE. THAT HAPPENED DURING THE MONTH OF JULY .... NOW MY BACK AUTOMATIC DOORS WILL NOT OPEN FROM THE INSIDE SWITCH LOCATED NEAR THE DOORS, AND MY PASSENGER SIDE WINDOW WAS ROLLED DOWN YESTERDAY (09/15/07) AND DIDN'T WANT TO GO BACK UP. I DID FINALLY GET IT UP BUT SCARED TO TRY AND ROLL IT DOWN AGAIN. *JB
Sep 16, 2007
Frequently Asked Questions
How many problems does the 2007 DODGE Grand Caravan have?
The 2007 DODGE Grand Caravan currently has 182 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.
What are the most common problems with 2007 DODGE Grand Caravan?
The most common problems reported for the 2007 DODGE Grand Caravan are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.
Where does this 2007 DODGE Grand Caravan problem data come from?
All problem and complaint data for the 2007 DODGE Grand Caravan comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.
Other Years - DODGE Grand Caravan
2025 Problems
2024 Problems
2023 Problems
2022 Problems
2021 Problems
2020 Problems
2019 Problems
2018 Problems
2017 Problems
2016 Problems
2015 Problems
2014 Problems
2013 Problems
2012 Problems
2011 Problems
2010 Problems
2009 Problems
2008 Problems
2006 Problems
2005 Problems
2004 Problems
2003 Problems
2002 Problems
2001 Problems
2000 Problems
1999 Problems
1998 Problems
1997 Problems
1996 Problems
1995 Problems
1994 Problems
1993 Problems
1992 Problems
1991 Problems
1990 Problems
Other DODGE Models
400
480 Series
580 Series
600
ARIES
Avenger
Caliber
Caravan
Caravan/Grand Caravan
Challenger
Charger
Chassis with Powertrain
Similar Brands
ST
3,555 models
RS
3,484 models
NC
2,822 models
ND
2,385 models
Z
1,951 models
MOTO
1,583 models
NU
1,189 models
RC
1,122 models