How many problems does the 2006 FORD Explorer have?

The 2006 FORD Explorer currently has 635 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2006 FORD Explorer?

The most common problems reported for the 2006 FORD Explorer are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2006 FORD Explorer problem data come from?

All problem and complaint data for the 2006 FORD Explorer comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.

2006 FORD Explorer Problems

POWER TRAIN

236 complaints

THIS TRANSMISSION SHOULD BE RECALLED!!!! THE REVERSE BAND BREAKS AND IS A KNOWN ISSUE FOR THIS TRANSMISSION!! NO WARNING JUST WENT TO REVERSE AND NOTHING! UPON RESEARCH THIS HAS BEEN A KNOWN ISSUE SINCE DAY ONE!!

Jul 26, 2023

THE TRANSMISSIONS HAVE A PROBLEM AND HAVE HAD A PROBLEM FOR YEARS. THEY CAN FAIL WITHOUT NOTICE AND CAUSE A VEHICLE TO LOSE MOMENTUM WHILE GOING DOWN THE ROAD. YES THIS IS AN OLDER VEHICLE BUT IF YOU LOOK UP OLDER COMMENTS ON THIS VEHICLE ON OTHER REPORTING SITES THERE ARE MANY REPORTS OF TRANSMISSIONS CAUSING SERIOUS PROBLEMS. WHY HAS THIS NEVER BEEN DEALT WITH IN ANY MANNER? I WAS DRIVING DOWN THE HIGHWAY AND MY VEHICLE BEGAN TO SLOW DOWN AND WOULD NOT MOVE FORWARD. I WAS ABLE TO GET THE VEHICLE IN GEAR AND GET IT TO THE SHOP. I PAID TO REPLACE THE TRANSMISSION AND IT DID IT AGAIN IN THE NEW TRANSMISSION. I ALMOST DID NOT MAKE IT UP THE HILL NEAR MY HOME AND HAVE BEEN FORCED TO PARK THE VEHICLE AS IT IS NOT SAFE TO DRIVE.

May 01, 2021

I WAS TURNING FROM TURNING LANE INTO WAL-MART AND WHEN I GAVE IT GAS THE TRANSMISSION SLIPPED AND WOULDN'T MOVE. LUCKILY NO CARS WERE COMING AND IT FINALLY KICKED IN AND LET ME PULL INTO THE PARKING LOT. I JUST BOUGHT THIS AND WAS LOOKING UP THE ISSUE AND FOUND OUT THIS IS A PROBLEM WITH FORD EXPLORER 2002 - 2006. WHY ISN'T THERE A RECALL ON THESE TRANSMISSIONS? THIS IS VERY DANGEROUS!

Oct 28, 2020

I PURCHASED A 2006 FORD EXPLORER, EDDIE BAUER. I NEEDED THE TRANSMISSION REBUILT AND PAID AAMCO ALMOST $4,000. NOT EVEN A YEAR LATER THE TRANSMISSION FAILED AND HAD TO BE RE-BUILT AGAIN BUT IT WAS UNDER WARRANTY. BACK IN MARCH 2019, I TOOK IT BACK TO AAMCO AND WAS TOLD NOTHING WRONG WITH THE TRANSMISSION. AUGUST 2019, I WENT BACK TO AAMCO AND THEY REPLACED THE SOLENOID PACK IS WHAT I WAS TOLD. NOW, NOT EVEN A MONTH LATER THE TRANSMISSION HAS FAILED AGAIN. THE SUV JERKS WHEN PLACED INTO GEAR AND IT FEELS AS THOUGH SOMEONE REAR ENDED ME. THE TRANSMISSION IS FAULTY BY THE MANUFACTURER, FORD! THERE ARE HUNDREDS OF COMPLAINTS REGARDING THE TRANSMISSION OF THIS YEAR EXPLORER WITH THE SAME ISSUES AND FORD WILL NOT TAKE RESPONSIBILITY! IT'S NOT RIGHT THAT CONSUMERS HAVE TO SHELL OUT THOUSANDS OF DOLLARS ON THIS PIECE OF JUNK THEY MANUFACTURED WHICH CAN CAUSE ACCIDENTS! SOMETHING HAS TO BE DONE.

Sep 18, 2019

WHEN THE CAR IS PUT IN REVERSE AND YOU GIVE IT GAS, IT SHIFTS REALLY HARD AND JERKS AND SLIPS. I THINK THAT SOMETHING IS WRONG WITH THE TRANSMISSION. THIS HAPPENED WHILE I WAS LEAVING WORK AND PUT THE CAR INTO REVERSE TO LEAVE THE PARKING LOT.

Oct 11, 2018

+ 231 more complaints for this component

ENGINE AND ENGINE COOLING

137 complaints

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THE RADIATOR WAS LEAKING FLUID. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 125,000.

Oct 03, 2014

THE RADIATOR IN THE 2006 FORD EXPLORER LEAKS, AND A RECALL IS MANDATORY. I BOUGHT THIS VEHICLE IN 2007, USED, AND I AM NOW FACED WITH REPLACING THE RADIATOR FOR THE 4TH TIME IN 7 YEARS. IT IS A KNOWN ISSUE THAT THIS RADIATOR IS FAULTY AND STILL THERE IS NO RESOLVE. PLEASE OPEN AN INVESTIGATION AND READ ALL THE COMPLAINTS REGARDING THE RADIATOR FOR THIS VEHICLE. *TR

Jul 17, 2013

THE RADIATOR LEAKS ON ALMOST ALL 2006 MODELS FROM THE FACTORY. FORD ACKNOWLEDGES THE ISSUE WAS FROM OVERTIGHTENING, YET DOES NOT ISSUE A RECALL. *TR

Jul 11, 2012

I HAVE BEEN HAVING SOME MISFIRING SPARK PLUGS ON MY TRUCK. WE ARE PRICING THEM OUT AND ARE FINDING OUT THAT THEY ARE VERY HARD TO REPLACE AND THEY BREAK OFF INSIDE THE ENGINE! DEALERS DO NOT RECOMMEND REPLACING THEM YOURSELF AND IT COSTS $300 TO HAVE THEM DO IT, THEN $100 FOR EVERY SPARK PLUG THAT BREAKS DURING THAT PROCESS, PLUS THE $19 FOR EACH MOTORCRAFT BRAND PLUG! THIS COULD COST US UP TO $1500 JUST TO REPLACE SPARK PLUGS?! THIS IS INSANITY!!! NOT ONLY DOES IT BUILD UP CARBON BUT IT IS ALSO A 2 PIECE PLUG AND IT BREAKS APART! THIS NEEDS TO BE RECALLED! PEOPLE ARE SPENDING A FORTUNE JUST TO REPLACE SPARK PLUGS! ITS SICK! *TR

Apr 27, 2012

SEPARATION OF RADIATOR ... BETWEEN PLASTIC TOP AND BOTTOM TANKS WITH ALUMINUM RADIATOR GRILL. THIS IS THE 2ND REPLACEMENT WITH COST $520 RADIATOR, $300 LABOR ESTIMATED BY FORD. ENVIRONMENTAL ISSUE AND SAFETY ISSUE WITH ENGINE FAILURE/TRANSMISSION FAILURE POSSIBLE. PROBLEM CAN OCCUR ANYWHERE/ANYTIME; I.E., WITHIN TRAFFIC SITUATION ON MULTILANE INTERSTATE RUSH HOUR. *JS

Apr 18, 2012

+ 132 more complaints for this component

ENGINE

21 complaints

The contact owns a 2006 Ford Explorer. The contact stated while driving at an undisclosed speed, the engine seized. The vehicle was driven to the shoulder of the road. The contact parked the vehicle and allowed the vehicle to set for a while. The vehicle was started. The contact stated that the vehicle was driven 100 yards before the failure reoccurred. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 150,000.

Nov 05, 2024

RADIATOR FLUID EXPLODED ALL OVER ENGINE AND FLOOR MASSIVE LEAK . SEARCHED IT UP ON INTERNET AND SEEMS THIS IS A COMMON PROBLEM WITH THIS VEHICLE . I STARTED VEHICLE AND FLUID STARTED GOING EVERYWHERE .I DROVE MAYBE 10 FEET AND SHUT THE CAR OFF IMMEDIATELY . *TR

Jun 09, 2020

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. WHILE DRIVING 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE, BUT THE FAILURE RECURRED TWO MORE TIMES. THE VEHICLE WAS TAKEN TO TRI STAR FORD (930 OLD US HWY 22, BLAIRSVILLE, PA 15717), BUT THE DEALER WAS UNABLE TO DIAGNOSE THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WERE NO RECALLS. THE CONTACT WAS ADVISED TO TAKE THE VEHICLE TO ANOTHER DEALER. THE APPROXIMATE FAILURE MILEAGE WAS 37,500. THE VIN WAS UNAVAILABLE.

Jun 05, 2017

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A COMPLETE LOSS OF POWER. IN ADDITION, THE CONTACT NOTICED STEAM COMING FROM THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE COMPRESSOR FAILED AND THE CHECK ENGINE INDICATOR WAS DISABLED. AS A RESULT, THE ELECTRONIC CONTROL MODULE CAUSED THE VEHICLE TO MALFUNCTION. THE COMPRESSOR WAS REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS APPROXIMATELY 109,000.

Sep 08, 2016

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. WHILE DRIVING VARIOUS SPEEDS, THEENGINESTALLED WITHOUTWARNING. THE VEHICLE RESTARTED AFTER NUMEROUS ATTEMPTS. THE VEHICLE WAS TAKEN TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED.THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE.THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE AND VIN WERE NOT AVAILABLE.

Jul 12, 2016

+ 16 more complaints for this component

POWER TRAIN,ENGINE

17 complaints

I OWN A 2006 FORD EXPLORER EDDIE BAUER , BOUGHT USED IN 2011/61000K. SINCE 2012 THE CAR STARTED SHOWING PROBLEMS WITH THE POWER STEERING AND /OR ENGINE. WHEN DRIVING AT 35-40 MPH ON A HIGHWAY THE CAR STARTED TO SURGE FORWARD, THEN BACK, KEEPING SURGING UNTIL THE CAR REACHED A HIGHER SPEED OF 60. IF DRIVING ON A HILL, IT WILL LOOSE ITS SPEED. I TOOK THE CAR TO FORD DEALER AND THEY COULDN'T FIND THE PROBLEM. THE CAR NOW IS 120000K, STILL SAME PROBLEM. VERY DISAPPOINTED WITH FORD THAT WILL NOT TAKE RESPONSIBILITY FOR THE PROBLEMAS.

Jul 12, 2017

GOT 2006 EDDIE BAUER W/98,000, 1 PREVIOUS OWNER (MOTHER) ALL SERVICING VIA THE SAME FORD DEALER (GENE BUTMAN), EXCEPT FOR A FEW OIL CHANGES FROM UNCLE ED'S. LATE NOV 2016 TOOK IT IN DUE TO THE HEAT WAS FLUCTUATING, WAS TOLD IT NEEDED THE THERMOSTAT AND HOUSING REPLACED (EVEN THOUGH IT HAD THE RADIATOR REPLACED A FEW YEARS EARLIER), ALSO HAD BRAKES & ROTORS DONE, THE 100,000 MILE CHECKUP SAID ALL WAS GOOD. A WEEK LATER THE EXHAUST FLUTE, ETC BROKE LOSE, GOT THAT REPAIRED & $2,000 LATER, FRIDAY 2/03/17 WRENCH LIGHT CAME ON, THEN ENGINE LIGHT, VEHICLE SEEMED TO LUNGE FORWARD, DELAY, DOESN'T ENGAGE..ACCELERATE, FEELS LIKE THE TRANSMISSION IS HANGING AND THEN SLAMS INTO GEAR. A THUD FEELING WAS ALSO REPORTED BY MY MOTHER SEVERAL TIMES IN PREVIOUS YEARS TO THE DEALER, THEY COULD NOT FIND ANYTHING WRONG, SO SHE HAD THEN DOCUMENT IT. TODAY I AM TOLD A TRANSMISSION IS NEEDED, WHICH IS A UNEXPECTED HUGE & SADDENING SURPRISE - IN 2012 AND 2013 THERE HAD ALREADY BEEN TRANSMISSION WORK ON THE VEHICLE. CHECKED AND SEE ALL REPORTS ABOUT THIS PARTICULAR MODEL HAS OCCURRED ON THIS ONE, COOLING SYSTEM/RADIATOR/THERMOSTAT AND HOUSING ISSUES, EXHAUST ISSUES AND NOW TRANSMISSION ISSUES -- THERE ARE THOUSANDS OF REPORTS FOR THIS EXACT MODEL AND OTHER EXPLORER AND FORD VEHICLES, ALL KNOWN ISSUES, MANY EXPLANATIONS WHY IT OCCURRED WITH THIS MODEL AND THAT FORD IS AWARE OF THEM AND HAS PROVIDED NO RECALLS FOR ANY OF THESE SERIOUS DEFECTIVE MATTERS, NONE - ESPECIALLY WHEN EACH ARE VERY DANGEROUS MATTERS. TODAY I AM TOLD, THAT A NEW TRANSMISSION WILL BE: $5,400, 3 YEAR WARRANTY AND A USED TRANSMISSION: $3,600 12 MOS OR 12,000 MILES. BOTH OPTIONS ARE VERY VERY EXPENSIVE. WHAT CAN NHTSA DO, WILL A RECALL EVER OCCUR? IT SEEMS FORD NEEDS TO STEP IN AND HELP WITH THESE REPAIRS. IT THERE ANY HELP WITH THESE MATTERS & COST? HTTP://WWW.CARCOMPLAINTS.COM/FORD/EXPLORER/2006/ .

Feb 08, 2017

PURCHASE THIS VEHICLE IN 2011 ONCE IT WAS HOME WITHIN 3 MONTHS BEGAN HAVING PROBLEMS, I ALSO PURCHASE THE FORD EXTENDED WARRANTY AND TOOK IT BACK TO THE DEALERSHIP. THEY EXPLAINED THEY COULD NOT FIND AN ISSUE WITH THE TRANSMISSION. IT JOLTS, LUNGES, AND SOMETIMES THE TRANSMISSION DOESN'T ENGAGE. I FEEL EXTREMELY UNSAFE TRYING TO PULL OUT AT AN INTERSECTION BECAUSE THE CAR STARTS TO JOLT AND I HAVE TO SLAM ON THE GAS IN ORDER FOR THE CAR TO GO.IT IS HORRIBLE AND I FEEL VERY UNSAFE DRIVING; ESPECIALLY WITH MY CHILDREN IN THE CAR. EVEN IF I AM DRIVING ON THE INTERSTATE I HAVE TO PUT THE CAR INTO OVERDRIVE TO STOP THE MAJORITY OF THE JOLTING, AND THAT DOES NOT EVEN GUARANTEE IT WILL STOP. IT HAS BEEN A BATTLE WITH THE DEALERSHIP. HAD IT INDEPENDENTLY CHECKED BY AAMCO AND THE TRANSMISSION REPLACED, BUT THE ISSUE STILL OCCURS. NOT SURE WHAT CAN BE DONE. THIS VEHICLE NEEDS TO BE RECALLED. *TR

Oct 29, 2014

I BOUGHT MY FIRST FORD EXPLORER ALMOST 8 YEARS AGO. I HAD ABSOLUTELY NO PROBLEMS WITH THIS VEHICLE AND FELT VERY SAFE DRIVING MY NEWBORN SON. I HAD A SECOND SON AND DECIDED TO BUY A NEW FORD EXPLORER BECAUSE IT WAS SUCH A DEPENDABLE CAR. NOW I AM REGRETTING THAT DECISION. I BOUGHT A 2006 FORD EXPLORER AT ROUND 60,000 MILES. IT NOW HAS 70,000 AND I HAVE ALREADY HAD TO GET ANOTHER TRANSMISSION AND IT STILL HAS NOT FIXED THE PROBLEM. IT JOLTS, LUNGES, AND SOMETIMES THE TRANSMISSION DOESN'T ENGAGE. I FEEL EXTREMELY UNSAFE TRYING TO PULL OUT AT AN INTERSECTION BECAUSE THE CAR STARTS TO JOLT AND I HAVE TO SLAM ON THE GAS IN ORDER FOR THE CAR TO GO.IT IS HORRIBLE AND I FEEL VERY UNSAFE DRIVING; ESPECIALLY WITH MY CHILDREN IN THE CAR. EVEN IF I AM DRIVING ON THE INTERSTATE I HAVE TO PUT THE CAR INTO OVERDRIVE TO STOP THE MAJORITY OF THE JOLTING, AND THAT DOES NOT EVEN GUARANTEE IT WILL STOP. MY HUSBAND IS IN THE MILITARY AND GONE A GREAT DEAL. HE SHOULD NOT HAVE TO WORRY ABOUT THE SAFETY OF HIS CHILDREN OR WIFE WHEN HE IS DEPLOYED OVERSEAS OR WHEN HE IS TRAINING AWAY FROM HOME. HE IS CURRENTLY AWAY FROM HOME FOR TRAINING, GETTING READY FOR DEPLOYMENT. HE IS CALLING EVERY CHANCE HE GETS TO MAKE SURE THE CAR HAS NOT BROKEN DOWN OR WE HAVE NOT BEEN IN AND ACCIDENT DUE TO THIS VERY HORRIBLE VEHICLE. IF I HAD ENOUGH MONEY I WOULD BUY ANOTHER VEHICLE AND TELL EVERYONE NOT TO EVER BUY A FORD AGAIN. I THINK I AM MORE UPSET WITH THE FACT THAT MY HUSBAND IS POSSIBLE BEING SENT OVERSEAS IN OCTOBER, AND HE CANNOT EVEN GO TO WAR WITH THE KNOWLEDGE HIS FAMILY IS SAFE. I REALLY WISH SOMEONE WOULD UNDERSTAND THAT THIS IS A HUGE PROBLEM AND MAJOR SAFETY PROBLEM. PLEASE HELP ALL OF THE FAMILIES WITH THIS DEFECT. *TR

Jul 17, 2014

I WAS DRIVING UP SMALL HILL-DRY CONDITIONS AND THE CAR SHUT DOWN. ON COMING VEHICLE SWERVED AND AVOIDED COLLISION. THIS HAS HAPPENED MANY TIMES AFTER THE TRACTION CONTROL SENSOR COMES ON. THE CAR ALSO JUMPS OUT WHEN SHIFTING GEARS AND SOMETIMES IT IS VERY HARD TO SHIFT. TRANSMISSION PROBLEM! SAFETY RECALL IMPERATIVE! *TR

Jun 28, 2014

+ 12 more complaints for this component

UNKNOWN OR OTHER

15 complaints

Transmission

Mar 31, 2023

I TOO HAD THE SAME PROBLEM AS I WAS COMING TO A FOUR WAY INTERSECTION. AS I WAS DRIVING ALL OF A SUDDEN A WRENCH TOOL CAME UP AND I COULD NOT ACCELERATE SO I HAD TO PULL OFF IN A PARKING LOT BEFORE I GOT TO THE INTERSECTION. I DID NOT WANT MY VEHICLE TO STALL AND I TURNED THE VEHICLE OFF AND PUT IT INTO NEUTRAL AND LET IT SIT THERE. I THEN TOOK IT OUT OF NEUTRAL AND STARTED IT BACK UP. I COULD FEEL THE JERKING AND FELT LIKE I GOT REAR ENDED IN THE BACK. MY HEAD JERKED FORWARD AS I WAS DRIVING WHILE IT KEPT JERKING.

Aug 26, 2020

STATIONARY-TURNED KEY ON,EXPLORER STARTED-PUT IN REVERSE- LIGHTLY TAPPED ACCELERATOR-EXPLORER WENT FULL THROTTLE.I APPLIED BRAKE WHITE TURNING KEY OFF. RESTARTED 3 TIMES WITH THE SAME RESULTS-THEN THE EXPLORER STARTED AND OPERATED IN A NORMAL WAY. 2 ACCIDENTS ONE WITH15,000 & ONE 5,000 PROPERTY DAMAGE. *TR

Jun 08, 2020

Crash: 1

ENGINE SHUT DOWN WHILE DRIVING APPROXIMATELY 10- 15 MILES WITHOUT NOTICE

Aug 21, 2018

2006 FORD EXPLORER, EDDIE BAUER EDITION. THE ELECTRONIC THROTTLE BODY (ETB) FAILS, BECOMES DEFECTIVE, AND HAS BEEN REPLACED FIVE TIMES IN LESS THAN TWO YEARS. WITHOUT WARNING, THE VEHICLE WILL DISPLAY POOR PERFORMANCE, ERRATIC RPM'S, LOOSE POWER, AND EVEN STALL. ALL INDICATIONS POINT TO THE ETB; CODES AND MECHANIC EXPERIENCE SUGGEST REPLACING ETB, ONLY TO HAVE SAVE ISSUE ARISE AGAIN IN TWO TO THREE MONTHS, IF NOT WEEKS, OR EVEN DAYS, AFTER REPLACEMENT. OFTEN, BUT NOT ALWAYS, THE "WRENCH" ICON (LIMP HOME) TURNS ON, AND, OFTEN, HOWEVER, NOT ALWAYS, THE CHECK ENGINE LIGHT. A RESTART OF VEHICLE, THE "WRENCH" ICON TURNS OFF, AND VEHICLE WILL DRIVE, HOWEVER, CONTINUES TO PERFORM POORLY. THE ABOVE OCCURS IN ALL KINDS OF WEATHER, AND TIMES OF DAY, OR YEAR, WITHOUT WARNING, NO MATTER THE DIVING CONDITIONS. THE PROBLEMS ARE INCONSISTENT AND IRREGULAR. THE SYMPTOMS MAY OCCUR ON FIRST START IN DRIVEWAY, ON BUSY STREET, OR IDLING IN SCHOOL PICK-UP LINE. WHEN THE ETB IS REPLACED, THE VEHICLE DRIVES AS MANUFACTURE INTENDED, DEMONSTRATING THE ISSUE IS WITH THE ETB, AS NUMEROUS MECHANICS HAVE DIAGNOSED, FROM THE FORD DEALERSHIP TO MANY NAME-BRAND AND LOCAL AUTO REPAIR SHOPS. THE REPLACED-ELECTRONIC THROTTLE BODIES PERFORM WELL FOR INCONSISTENT TIME PERIODS NO MATTER OF THE MANUFACTURER. OEM ETB DO NOT SEEM TO LAST ANY LONGER THAN AFTER-MARKET ETB'S.

Jun 19, 2018

+ 10 more complaints for this component

ELECTRICAL SYSTEM

13 complaints

WHILE DRIVING WE TURNED ON THE AC AND WE HERD A BIG POP. THEN THE PASSENGERS LEG GOT WARM. THEN WE FELT AROUND IT KEPT GETTING HOTTER. IT FOLLOWED THE DASH THEN SMOKE ROLLED OFF UNDER THE DASH. I THREW IT IN PARK WE JUMPED OUT THE FLAMES CONSUMED THE VEHICLE. WE WERE ON A ROAD.

Jul 12, 2016

Fire: 1

THE ISSUE BEING, DIGITAL ODOMETER FAILURE,AND FORD UNABLE TO PROVIDE REPLACEMENT INSTRUMENT CLUSTER COMPONENT. NOW WE ARE CONTRIBUTING TO THE POLUTION OF THE ENVIRONMENT AS I AM UNABLE TO MONITOR MY ENGINE PERFORMANCE, HAVE NO IDEA WHEN TO CHANGE OIL, CONTRIBUTING TO PREMATURE ENGINE FAILURE, AND UNABLE TO HAVE MY VEHICLE INSPECTED, RENDERING MY VEHICLE INOPERABLE

Jul 16, 2011

TL*THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT HER VEHICLE STALLED WHILE SHE WAS DRIVING 50 MPH. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO STATED THERE WAS NO FAILURE. NEITHER THE DEALERSHIP OR MANUFACTURER WERE CONTACTED. THE FAILURE MILEAGE WAS 5,000 AND THE CURRENTLY MILEAGE WAS 35,000.

May 31, 2011

FORD 2006 EDDIE BAUER EXPLORER. DRIVING VEHICLE AND AT A STOP AT A STOP LIGHT THE ABS LIGHT TURNED ON WITH ROUGH LEFT TO RIGHT SHIFTING OF THE VEHICLE AS IF IT WAS BEING SHAKEN IN AN EARTHQUAKE. WHEN THE LIGHT TURNED GREEN AND I STEPPED ON THE ACCELERATOR IT WOULD NOT GO. NUMEROUS LOUD CLICKING WAS HEARD AND THE SHAKING CONTINUED. THE VEHICLE STARTED TO MOVE SLOW AND I PULLED OVER AND TURNED THE VEHICLE OFF FOR ABOUT 7 MINUTES. I RESTARTED VEHICLE AND ABS LIGHT, CLICKING ANG VIOLENT LEFT TO RIGHT SHAKING CONTINUED. THE FORD DEALERSHIP WAS A BLOCK AWAY AND I PROCEEDED TO DEALERSHIP AT ABOUT15-20 MILES PER HOUR. AS I PROCEEDED THE WRENCH LIGHT CAME ON FOLLOWED BY THE RSC LIGHT. IT WAS A VERY DANGEROUS SITUATION AS I WAS IN TRAFFIC. THE DEALERSHIP REPORTED THAT IT WAS AN ABS TONE RING THAT CAUSED THE MALFUNCTION AND THAT FOR SOME REASON THE CLUSTER AND COMPASS HAD MALFUNCTIONED CAUSING THE OTHER LIGHTS TO ILLUMINATE. THE TOTAL COST IS$1300.00 FOR REPAIR AND THIS WAS OVER TWO WEEKS AGO STILL HAVE NOT RECEIVED VEHICLE. I HIGHLY SUSPECT THAT THE RELATED CLUSTER MALFUNCTION IS RELATED TO SUPPOSED TOE RING MALFUNCTION AS DEALERSHIP HAS BEEN VERY IFFY ABOUT THE REPAIR AND HAVE AVOIDED MY PHONE CALLS REQUESTING UPDATE. VEHICLE HAS ABOUT 46000 MILES AND IS STILL UNDER WARRANTY, BUT DEALER STATES ALL MALFUNCTIONS ARE NOT COVERED UNDER WARRANTY. *TR

Mar 20, 2011

2006 FORD EXPLORER WITH 42,000 MI HAS JUST STARTED TO DIE. DANGEROUS BECAUSE IT QUITS RUNNING IN TRAFFIC ,NO BRAKE LIGHTS , SO TRAFFIC BEHIND DOES NOT EXPECT YOU TO STOP. *TR

Sep 07, 2010

+ 8 more complaints for this component

FUEL SYSTEM, GASOLINE

13 complaints

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THE WHILE REFUELING, FUEL BEGAN TO LEAK FROM THE VEHICLE. THE CONTACT WAS UNABLE TO REFUEL THE VEHICLE AS GASOLINE OVERFLOWED. THE VEHICLE WAS TAKEN TO THE DEALER, WHO REPLACED THE FUEL SENDING UNIT, SENSORS AND TUBES. THE FAILURE WAS NOT CORRECTED AND LATER RECURRED. THE FAILURE WAS REPORTED TO THE MANUFACTURER. THE FAILURE MILEAGE WAS 70,000. THE CURRENT MILEAGE WAS 90,000. UPDATED 8/19/13 *CN THE CONSUMER STATED SHE HAS BEEN TWO SEVERAL DEALERS FOR THE SAME PROBLEM. UPDATED 09/05/13

Jul 09, 2013

THEE HAVE BEEN ONGOING ISSUES WITH THE FUEL SYSTEM DATING BACK TO 2009 FUEL SYSTEM SOLENOID AND VENT. IT HAS BEEN REPAIRED AT LEAST THREE TO FOUR TIMES FOR THE EXACT SAME REPAIR AND THE SAME PARTS EVERY TIME. THE FUEL SYSTEM DOES NOT ALLOW THE GAS TANK TO BE FILLED AT A NORMAL RATE. IT TAKES AS LONG AS 45 SECONDS SOMETIMES TO PUT ONE (1) GALLON OF GAS IN THE TANK. IT CAN TAKE WELL OVER 10 MINUTES TO FILL THE GAS TANK SOMETIMES. I HAVE TRIED TO DEAL WITH CUSTOMER SERVICE REPRESENTATIVES AT FORD AND THEY HAVE BEEN OF NO ASSISTANCE WHATSOEVER. *TR

Jun 18, 2013

WHEN ATTEMPTING TO ADD GASOLINE TO THE TANK, GAS SHOOTS OUT OF THE TANK AT THE NOZZLE AREA AS IF THE TANK IS FULL. GAS MUST BE ADDED AT AN EXTREMELY SLOW RATE IN ORDER TO FILL THE TANK. EVEN WHEN ADDING GAS TO THE TANK AT THE EXTREMELY SLOW RATE THE PUMP WILL CONTINUE TO KICK OFF EVERY FEW SECONDS. *TR

Jan 25, 2013

I OWN A 2006 FORD EXPLORER. THE VEHICLE EXPERIENCE A FAILURE ON THE FUEL FILL SYSTEM IN 2008. I WAS NOT ABLE TO PUT MORE THAN A GALLON OF GAS IN AT A TIME, WAIT FOR AWHILE, ADD ANOTHER GALLON, ETC AS THE FUEL FILL WOULD ACT AS THOUGH THE TANK WAS FULL. TOOK TO A DEALER AND HAD IT REPLACED BASED ON TSB#07253. EXPERIENCED THE SAME FAILURE AGAIN NOW IN 2011 AND BROUGHT IT BACK TO THE DEALER AND WAS TOLD SINCE IT WAS MORE THAN 12 MONTHS SINCE THE ORIGINAL REPLACEMENT I HAD TO PAY THE DEDUCTIBLE AGAIN TO HAVE THE WORK DONE. *TR

May 27, 2011

FUEL BACKS OUT WHEN FILLING,CAN ONLY GET 2 OR 3 GALLONS BEFORE FUEL SPRAYS OUT ALL OVER. CHECK ENGINE LIGHTS. *TR

Apr 26, 2011

+ 8 more complaints for this component

VEHICLE SPEED CONTROL

12 complaints

WHEN THE SPEED CONTROL IS ENGAGED AND I AM RUNNING BETWEEN 40 AND 45 MPH AND DRIVING ON GENTLY ROLLING HILLS THE ENGINE WILL TURN OFF LEAVING ME NO POWER FOR BRAKES OR STEERING - NO CONTROL!

Nov 14, 2015

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. WHILE AT A STOP SIGN, THE VEHICLE ACCELERATED INDEPENDENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 34,600.

Dec 29, 2014

WHILE DRIVING 2006 FORD EXPLORER SHUTS DOWN SEVERAL TIME AT DIFFERENT OCCASION SOMETIMES A LITTLE WRENCH APPEARS AND GAS PEDAL BECOMES UNRESPONSIVE AND CRUISE CONTROL CAN NOT BE ENGAGE AND VEHICLE IDLE VERY ROUGH WHEN COME TO A STOP. VEHICLE HAS LOSS ACCELERATION WHILE RUNNING ON 6 LANES HIGHWAY AND REQUIRE TO BE PULL ALONG THE SIDE TO TURN OFF AND RESTART AGAIN, WHEN VEHICLE SHUTS DOWN IT DOES NOT ALWAYS RESTART RIGHT AWAY. WHEN I BRING IT FOR DIAGNOSTIC FORD DEALERS ARE UNABLE TO DO ANYTHING BECAUSE THE SYMPTOMS CAN NOT BE DUPLICATED AND NO FAULT ARE STORE. IT HAPPEN AGAIN SUNDAY AUGUST 21 2011 WHILE I WAS DRIVEN FROM NJ TO NY ON I-80 AND THIS TIME CHECK ENGINE LIGHT CAME ON AND TOOK IT TO AUTO-ZONE AND THEY READ CODES P2104 AND P2111. BY THE TIME I WENT TO THE DEALER AND TURN OFF THE VEHICLE CHECK ENGINE LIGHT WAS GONE THE COULD NOT DO ANYTHING. *TR

Aug 23, 2011

TL*THE CONTACT OWNS A 2006 FORD EXPLORER. WHILE STOPPED, THE VEHICLE ATTEMPTED TO SURGE FORWARD BUT THE CONTACT KEPT PRESSURE ON THE BRAKE PEDAL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE AN UNKNOWN REPAIR WAS PERFORMED ON THE VEHICLE. THE FAILURE CONTINUED TO OCCUR INTERMITTENTLY WHILE STOPPED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 10,438.

Jan 31, 2011

TL*THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 10 MPH IN REVERSE AND APPLYING THE BRAKES, HIS FOOT HIT THE ACCELERATOR PEDAL. THE VEHICLE HIT A MAILBOX AS A RESULT BUT THERE WERE NO DAMAGES OR INJURIES. THE FAILURE OCCURRED FIVE TIMES TOTAL WHEN HE WAS APPLYING THE BRAKES. THE CONTACT BELIEVED THAT THE TWO PEDALS WERE TOO CLOSE TO ONE ANOTHER. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 5,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 46,000.

Sep 28, 2010

Crash: 1

+ 7 more complaints for this component

SERVICE BRAKES, HYDRAULIC

11 complaints

WHEN I WAS DRIVING, 3 DASHBOARD LIGHTS CAME ON: THE WRENCH, THE ABS LIGHT, AND THE LOW TRACTION. WHEN I TURNED LEFT, THE RIGHT REAR WHEEL GRABBED AND MADE A GRINDING SOUND. THERE WAS ALSO A HIGHER PITCHED NOISE THAT SOUNDED LIKE METAL STRIKING METAL. THE MECHANIC HAS STATED THAT THE TONE RING BROKE ON THE RIGHT REAR DRIVE AXLE, AND THIS IS A COMMON FORD PROBLEM. WHEN IT BROKE, IT DAMAGED THE BRAKE UNIT ON MY RIGHT REAR WHEEL AS WELL. THE REPAIR ISN'T CHEAP - I WISH I WOULD HAVE KNOWN THIS WAS A POSSIBILITY WHEN I BOUGHT THE VEHICLE. *TR

May 09, 2012

I OWN A 2006 FORD EXPLORER WITH ONLY 64,000 MILES AND THE TONE RINGS ON THE ABS BRAKES HAVE BOTH CRACKED, NOT COSTING ME OVER $1000 IN REPAIR BILLS. THIS IS AN ITEM THAT SHOULD NOT CRACK WITH ONLY 64K MILES OF USE. *TR

Feb 23, 2011

WHEN I HIT THE BRAKES IN AN EMERGENCY, AND SOMETIMES AT OTHER TIMES, MY FOOT STRIKES THE GAS PEDAL TOO CAUSING THE MOTOR TO REV UP AND NOT STOP TIMELY WHICH HAS CAUSED ME TO ALMOST HAVE A SERIOUS ACCIDENT ON AT 3 OCCASIONS. I HAVE HAD IT CHECKED AND FORD MOTOR CO SAYS THEY HAVE HEARD OF THE PROBLEM BEFORE BUT THERE IS NOTHING THEY CAN DO ABOUT IT AND IT CAUSES ME GREAT SAFETY CONCERNS. ONCE A SEMI TRUCK PULLED OUT IN FRONT OF ME ON A HIGHWAY AND I BARELY AVOIDED AN ACCIDENT AS THE FORCE OF THE MOTOR WOULD NOT LET THE BRAKES HAVE FULL EFFECT. *TR

Mar 03, 2010

I HAD JUST LEFT THE GYM WHEN MY 2006 EXPLORER ALMOST CAUSED AN ACCIDENT. DURING ACCELERATION WHILE MAKING A RIGHT HAND TURN FROM A STOP LIGHT, THE CAR STOPPED ABRUPTLY AS IF I WERE SLAMMING ON THE BRAKES. I WAS NOT APPLYING THE BRAKES AT ALL, I WAS ACTUALLY TRYING TO ACCELERATE. THE BRAKES WERE STOPPING THE VEHICLE RAPIDLY WITHOUT MY INPUT. I WAS VERY CLOSE TO BEING REAR ENDED. I DECIDED TO PULL THE CAR TO A SAFE SPOT AND WHILE I WAS TRYING TO TURN INTO A PARKING LOT, THE CAR DECIDED TO STOP ITSELF, ALMOST GETTING ME REAR ENDED AGAIN. I HAD THE EXPLORER TOWED TO THE NEAREST DEALER WHERE REPAIRS WERE PERFORMED AT THE TUNE OF $423.78. THE ABS TONE RING HAD CRACKED, CAUSING THE SYSTEM TO STOP THE CAR. I STILL HAVE THE OLD BROKEN TONE RING. I AM ALMOST NERVOUS DRIVING THE THING AT HIGHER SPEEDS FOR FEAR OF WHAT MIGHT HAPPEN IF IT BRAKES AGAIN. WOULD THE SUV ROLL OR CAUSE A BAD ACCIDENT IF THE BRAKES WERE APPLIED SO VIOLENTLY AT HIGHWAY SPEEDS WITHOUT ANY DRIVER INPUT? *TR

Feb 16, 2010

ABS FAILURE IN 2006 FORD EXPLORER. DEALER REPAIR SHOP IDENTIFIED BROKEN SENSOR RING ON LEFT-REAR WHEEL. REQUIRED EXPENSIVE REPLACEMENT OF AXLE. CAR HAS ONLY 36,000 MILES AND A LITTLE OVER 3 YEARS OLD. *TR

Nov 09, 2009

+ 6 more complaints for this component

ENGINE AND ENGINE COOLING,POWER TRAIN

10 complaints

I BOUGHT MY FORD EXPLORER IN 2006 BUT THREE YEARS LATER HAD TO REPLACE THE RADIATOR. AFTER THAT I NOTICE THAT THE TRANSMISSION WOULD SLIP EVERY NOW AND THEN. THE PROBLEM SEEMS TO HAVE ESCALATED SINCE JUNE 2013 WITH THE VEHICLE JACKING OR DRAGGING BEFORE SHIFTING GEARS. MY WIFE IS ACTUALLY AFRAID OF DRIVING THIS VEHICLE AND INSTEAD PREFERS TO DRIVE MY 2000 HONDA ACCORD WHICH HAS BEEN RUNNING WITH NO PROBLEMS. I TOOK THE VEHICLE TO MY MECHANIC WHO TOLD ME THIS HAS BEEN A PROBLEM WITH THE MODEL AND YEAR OF MY FORD EXPLORER AND THAT THE TRANSMISSION WILL NEED TO BE REPLACED AND SO HE TOLD ME I SHOULD FILE THIS COMPLAIN SINCE THIS WAS NOT OUR FAULT BUT A FACTORY DEFECT WHICH BY THE LOOK OF WHAT I HAVE SEEN ON THIS SITE, FORD IS AWARE OF. MY QUESTION IS WHY HAS FORD NOT RECALLED THIS BECAUSE AFTER CHECKING THIS SITE, I HAVE SEEN SO MANY COMPLAINS ABOUT THE SAME RELATED ISSUES (MAINLY RADIATOR AND TRANSMISSION), ARE CUSTOMERS SUPPOSED TO SUFFER AND SPEND MONEY FOR THINGS THAT THE FORD COMPANY HAS NEGLECTED OR FOR THEIR POOR WORKMANSHIP? I BELIEVE NOT. FORD NEEDS TO GET THEIR ACT TOGETHER AND SOLVE THIS PROBLEMS FOR THEIR CUSTOMERS. I, JUST LIKE EVERYONE WHO BOUGHT A FORD EXPLORER WOULD LIKE TO SEE OUR AUTOMAKERS DOING WELL AND THAT'S WHY WE BUY THE CARS BUT NOT AT THE EXPENSE OF OUR FAMILIES SAFETY OR FINANCES. *TR

Jan 01, 2014

VEHICLE WAS JUST AT THE FORD DEALERSHIP FOR OVER A WEEK IN MARCH FOR TRANSMISSION RELATED ISSUES, NEW RADIATOR, ETC. JUST FOUR MONTHS LATER, I AM HAVING THE SAME ISSUES THAT MANY OTHERS ARE WRITING ABOUT; HARD SHIFT INTO REVERSE, VEHICLE IS JUMPING/JOLTING FORWARD FROM A STOP, RPM FLUCTUATION WHILE IDLING. *TR

Jul 04, 2013

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT DEPRESSED THE ACCELERATOR PEDAL BUT THE VEHICLE HESITATED TO ACCELERATE. THE VEHICLE THEN RAPIDLY ACCELERATED TO APPROXIMATELY 60 MPH AND BEGAN TO DECELERATE INDEPENDENTLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN ADVISED THE CONTACT THAT THE TRANSMISSION WOULD HAVE TO BE REBUILT OR REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 74,000. UPDATED 02/20/13*LJ THE CONSUMER STATED THERE WAS AN EMMISSION ISSUE AND THE RADIATOR WAS LEAKING. UPDATED 02/20/2013 *JS

Nov 28, 2012

I DISCOVERED A LEAK IN THE RADIATOR AFTER NOTICING THAT THE TEMPERATURE GAUGE NEEDLE WAS BOUNCING AROUND AT AN IDLE. AFTER ABOUT A MINUTE, THE VEHICLE OVERHEATED AND STARTED STEAMING. WE ENDED UP HAVING TO HAVE THE RADIATOR REPLACED AT A COST OF $600. (IT WAS ALSO OVER 90 DEGREES THAT DAY AND I WAS STRANDED WITH TWO SMALL CHILDREN, THE YOUNGEST WAS 4 MONTHS OLD.) THEN ABOUT A MONTH AGO, IN MAY 2012, I WAS AT A GROCERY STORE AND WHEN I WENT TO ENTER THE VEHICLE I NOTED A LARGE PUDDLE OF ANTIFREEZE ON THE GROUND AND IT WAS DRIPPING FROM THE RADIATOR. WE HAD TO HAVE THE RADIATOR REPLACED, AGAIN AT A COST OF $600. THE SAME MECHANIC REPAIRED IT BOTH TIMES AND SAID IT WAS THE SAME ISSUE AS THE FIRST ONE. NOW WE ARE HAVING TRANSMISSION FLUID LEAKING FROM THE COOLING LINE THAT LEADS FROM THE TRANSMISSION TO THE RADIATOR. THESE INCIDENTS HAVE CAUSED US SERIOUS HARDSHIPS FINANCIALLY AND COULD HAVE CAUSED PHYSICAL INJURY DUE TO THE FACT THAT IT WAS EXTREMELY HOT OUT ON BOTH OCCASIONS AND I HAD SMALL CHILDREN WITH ME MILES FROM HOME. I HAVE ALREADY CONTACTED FORD MOTOR COMPANY AND THEY HAVE DECLINED TO DO ANYTHING ABOUT THIS ISSUE. I AM REQUESTING, AS ARE MANY OTHERS, THAT A RECALL BE ISSUED. AND I ALSO SUGGEST THAT YOU RESEARCH THIS PROBLEM ON THE INTERNET AS IT IS A MAJOR ONE. IT IS STRANGE THAT FORD CHANGED THE RADIATOR IN THE 2007 MODEL YEAR EXPLORER. *TR

Jun 04, 2012

I HAVE A 2006 FORD EXPLORER XLT AND THIS WILL BE THIRD TRANSMISSION TO GO INTO THE VEHICLE. IN ADDITION, I HAVE REPLACED THE RADIATOR THREE TIMES AND AN ENGINE BLOCK SEAL. THESE ARE VERY COSTLY FIXES FOR A CAR THAT IS ONLY A COUPLE OF YEARS OLD. I HAVE REACHED OUT TO FORD CUSTOMER SERVICE AND THEY ARE NOT HELPFUL OR SYMPATHETIC AT ALL AND CLAIM THAT THEY ARE NOT AWARE OF ANY TRANSMISSION PROBLEMS. MEANWHILE, WHEN YOU SEARCH THE WEB IT IS AN ISSUE ACROSS THE BOARD. I FEEL THEIR CUSTOMER SERVICE IS HORRIBLE AND SO ARE THEIR CARS. I WOULD NEVER RECOMMEND A FORD TO ANYONE, NOT EVEN MY WORST ENEMY. I COULD HAVE BOUGHT TWO CARS FOR THE MONEY I AM PUTTING INTO THIS VEHICLE. *TR

May 08, 2012

+ 5 more complaints for this component

VISIBILITY

8 complaints

I OWN A 2006 FORD EXPLORER EDDIE BAUER MODEL. SIX MONTHS AFTER PURCHASE, THE REAR WIPER BLADE STOPPED WORKING. I CALLED THE DEALER WHICH I PURCHASED IT FROM AND THEY TOLD ME IT IS NOT COVERED AND A NEW MOTOR WOULD COST $300 PLUS LABOR. I FEEL THIS IS A SAFETY ISSUE BECAUSE WITH THE HEAVY SNOWS AND RAIN IN MY AREA, A MALFUNCTIONING REAR WIPER COULD CAUSE AN ACCIDENT. I KNOW OF 4 OTHER PEOPLE WITH THE SAME PROBLEM WITH THE SAME VEHICLE. I CALLED FORD HEADQUARTERS TO FILE A COMPLAINT AND THEY SAID THERE WAS NOTHING THEY CAN DO. PLEASE LOOK INTO THIS PROBLEM AND I AM SURE I AM NOT THE ONLY PERSON COMPLAINING OF THIS ISSUE. *TR

Dec 13, 2010

TL*THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THE WINDSHIELD WIPER MADE A POPPING NOISE AND DISCONNECTED FROM THE MOTOR WHICH CAUSED A LOSS OF VISIBILITY. THE DEALER STATED THAT THE FAILURE WAS NORMAL. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THEY WOULD PASS THE INFORMATION ON. THE VEHICLE WAS REPAIRED BY THE DEALER. THE FAILURE MILEAGE WAS 40,101 AND THE CURRENT MILEAGE WAS APPROXIMATELY 50,000.

Nov 30, 2010

TL*THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 55 MPH IN THE RAIN, THE REAR WINDSHIELD WIPER SUDDENLY MALFUNCTIONED WHICH MADE IT DIFFICULT TO SEE OUT OF THE REAR WINDOW. THE CONTACT REFERENCED RECALL 05V520000 (VISIBILITY: WINDSHIELD WIPER/WASHER: MOTOR) BUT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 82,000.

Oct 18, 2010

WHILE TRYING TO TURN ON THE AIR CONDITIONING, A CLICKING CAN BE HEARD AND THE AIR FLOW DOES NOT CHANGE OVER. THEN DURING COOLER DAYS THE HEAT IS INOPERATIVE, (IT STAYS ON COLD AIR) THE CLICKING IS PERSISTENT. *TR

Nov 24, 2009

1. THE EVENTS LEADING UP TO THE FAILURE ARE SIMPLE. IT WAS A QUIET SATURDAY AFTERNOON (4:30 PM ON 7/18/09). I WAS ON A TWO WAY STREET ON THE WAY TO MY SWEETHEART'S HOUSE IN OVERLAND PARK, KS . I WAS GOING AT ABOUT 25 MPH. THERE WAS ONE OTHER CAR IN MY VISION ABOUT 75 FEET BEHIND ME. NO ONE WAS COMING AT ME. TO MY RIGHT WAS AN EMPTY BASEBALL DIAMOND FOR THE LOCAL HIGH SCHOOL AND TO MY LEFT WAS A LARGE ( AT LEAST 10 FEET TALL) CONCRETE WALL ENCLOSING AN UPSCALE HOUSING DEVELOPMENT. 2. WITHOUT WARNING I HEAR AN EXPLOSION FOLLOWED IMMEDIATELY BY SHATTERING GLASS FROM MY SUNROOF CASCADING DOWN UPON ME. THE EXPLOSION WAS JUST THE SOUND OF THE SUNROOF SHATTERING. AS GOD IS MY WITNESS, I SWEAR TT JUST SHATTERED FROM CAUSES BEYOND MY KNOWLEDGE. 3. THE FOLLOWING MONDAY MORNING I TOOK IT TO THE FORD DEALERSHIP WHERE I HAD PURCHASED IT AND REPLACED THE SUNROOF. MY BUMPER-TO-BUMPER WARRANTY WAS STILL IN FORCE BUT FORD MOTOR REFUSED TO HONE UP ON THIS ONE. THE SERVICE MANAGER SAID THAT FORD DOESN'T KNOW BUT WHAT IT WAS SHOT OUT ACCIDENTALLY BROKEN OUT OR IF SOMEONE HAD PUT THEIR FIST THROUGH IT. THE STRANGE THING WAS THE SUNROOF GLASS THAT WAS STILL IN THE SUNROOF FRAME WAS ANGLING UPWARD AS IF IT HAD BEEN STRUCK FROM INSIDE. THE SERVICE MANAGER POINTED THIS OUT TO ME. THE LOCAL DEALERSHIP DID SPLIT THE COST OF REPLACEMENT WITH ME THOUGH. *TR

Jul 28, 2009

+ 3 more complaints for this component

SEATS

7 complaints

DRIVERS POWER SEAT IS LOOSE. PROBLEM APPEARS TO BE RELATED TO TRACK. SEAT FEELS LOOSE AND MOVES FORWARD OR BACKWARD DEPENDING ON ACCELERATION OR BRAKING. THE BIGGEST PROBLEM IS HOW DISTRACTING THIS IS. THE AMOUNT OF MOVEMENT SEEMS TO BE GETTING GREATER AND GREATER.

Apr 20, 2018

TL*THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THERE IS NOT ENOUGH PADDING ON THE FRONT DRIVER SIDE SEAT OF THE VEHICLE. THE DEALER RECOMMENDED TAKING THE VEHICLE TO AN UPHOLSTER SHOP. THE UPHOLSTERER ADDED MORE PADDING TO THE FRONT SEAT AND THE CONTACT STATED THAT THIS MADE THE SEAT MORE COMFORTABLE. THE CURRENT MILEAGE IS 55,000 AND FAILURE MILEAGE WAS 1,200. THE CONSUMER STATED THIS IS A COMPANY CAR AND USES THE VEHICLE FOR TRANSPORTATION TO AND FROM SALES LOCATIONS. THE CONSUMER PROVIDED COPY OF LETTERS TO FORD PERTAINING TO THE DEFECT , COPY OF REGISTRATION, AND INSURANCE CARD. THE CONSUMER STATED THE DISCOMFORT OF THE SEAT CAUSED HIS LEG TO BECOME SWOLLEN AND UPON SEEKING MEDICAL TREATMENT, IT WAS DISCOVERED HE SUFFERED A DEEP VEIN THROMBOSIS AND A BLOOD CLOT HAD BROKEN LOOSE AND CAUSED A PULMONARY EMBOLISM. THE VEHICLE IS A COMPANY OWNED. UPDATED 08/07/07 *TR

Jun 06, 2007

Injuries: 1

THE HEAD REST ON THE REAR SEATS OF THE 2006 FOR EXPLORER POSE A SERIOUS VISION OBSTRUCTION. YOU CANNOT SEE WHEN BACKING UP OR CHANGING LANES. IF YOU HAVE A CAR SEAT IN THE BACK SEAT YOU CANNOT LET THE HEAD REST DOWN. YOU ALSO CANNOT MOVE THE HEAD REST UP OR DOWN, ONLY TILT THE HEAD REST FORWARD. *JB

Nov 26, 2006

UNDER THE FRONT DRIVER AND PASSENGER SEAT, THERE IS SURFACE RUST ON THE METAL FRAME AND COMPONENTS. RUST IS NOT LIKELY SERIOUS, BUT CAN STAIN ANYTHING IT TOUCHES, AND MAY PROGRESS TO MORE SERIOUS RUST, CAUSING PARTS TO BREAK DOWN, OR MALFUNCTION. DEALER I BOUGHT VEHICLE FROM CALLED FORD SERVICE CENTER, AND FORD IS AWARE OF THE PROBLEM, AND AS THEY DEEM IT "NORMAL WEAR AND TEAR" IT IS NOT COVERED BY ANY SORT OF WARRANTY. NORMAL WEAR AND TEAR??? RUST INSIDE A NEW VEHICLE??? CHECKED OTHER EXPLORERS ON THE LOT AND THEY ALSO HAVE THE SAME PROBLEM. *NM

Oct 25, 2006

THE HEADREST ON THE REAR SEATS OF THE 2006 FOR EXPLORER POSE A SERIOUS VISION OBSTRUCTION. YOU CANNOT SEE OUT OF THE SIDE OF THE VEHICLE FOR PASSING OR CHANGING LANES. IF YOU HAVE A CAR SEAT IN THE BACK SEAT YOU CANNOT LET THE HEADREST DOWN. YOU ALSO CANNOT MOVE THE HEADREST UP OR DOWN, ONLY TILT THE HEADREST FORWARD. *NM

Oct 12, 2006

+ 2 more complaints for this component

POWER TRAIN,ELECTRICAL SYSTEM

7 complaints

MY 2006 EXPLORER HAS RECENTLY STARTED SHIFTING HARD AND SOMETIMES WILL NOT SHIFT INTO GEAR RIGHT AWAY. WHEN I PULL UP TO A STOP LIGHT OR BECOME STATIONARY IT WILL TRY TO DIE AND SOMETIMES WILL. AND WILL ALSO NOT GO INTO GEAR UNLESS I GIVE IT A LOT OF GAS AND THEN IT TAKES A MINUTE TO PICK UP COMPLETE SPEED. I HAVE ALREADY HAD TO REPLACE MULTIPLE THINGS ON THIS VEHICLE AND AM SEEING THAT OTHERS HAVE BEEN HAVING THE SAME TROUBLE. FORD DO THE RIGHT THING AND RECALL THIS VEHICLE. ALSO MY INTERIOR LIGHTS HAVE GONE OUT AND IS NOT THE FUSE OR BULBS.

Mar 15, 2016

IN THE LAST 2 YEARS I HAVE CONTINUED TO HAVE PROBLEMS WITH THIS VEHICLE WHICH HAS COST ME A LOT OF TIME AND MONEY. SIMILARLY TO THE MAJORITY OF THE COMPLAINTS LISTED THE VEHICLE JOLTS AND HESITATES WHILE IN MOTION. I HAVE BEEN TO REPAIR SHOP MORE TIMES THAN I CAN COUNT.... AND NOT EVEN THE TECHNICIANS AT FORD SEEM TO KNOW WHAT TO DO AS I CONTINUE TO HAVE THE SAME ISSUE. ON MY LAST VISIT TO THE SHOP ( A WEEK AGO) I WAS TOLD THAT THERE WAS A PROBLEM WITH THE COMPUTER WHICH WORKS LIKE "THE BRAIN OF THE TRUCK" BUT THEY COULDN'T FIGURE IT OUT SO THEN I WAS ENCOURAGED " TO LOOK AT "SOMETHING NEW(ER)". I QUESTIONED WHY I SHOULD BE DOING THAT WHEN THE VEHICLE HAS ONE 93K MILES ON IT.... AND WHY WOULD I BUY ANOTHER FORD VEHICLE WHEN THEY COULDN'T FIX OR FIGURE OUT WHAT WAS GOING ON WITH THE ONE I HAVE!!!!???? BASED ON THE NUMBER OF COMPLAINTS DIRECTLY ABOUT THIS SAME ISSUE ,I AM CONFIDENT THAT THERE IS A LARGER PROBLEM OF WHICH FORD IS AWARE AND REFUSES TO ADDRESS. I AM AFRAID EVERY TIME I DRIVE AS I DO NOT KNOW OR HAVE MUCH CONFIDENCE THAT IT WILL OPERATE AS INTENDED. AFTER CALLING FORD'S CUSTOMER RELATIONS CENTER, I WAS TOLD THAT MY ONLY OPTION WAS TO TAKE IT TO THE FOR REPAIR SHOP EVEN IF THEY DID NOT KNOW AND HAS MADE IT CLEAR THAT THEN CANNOT IDENTIFY OF FIX THE PROBLEM. *TR

Nov 07, 2014

ENGINE SERVICE LIGHT (THROTTLE CONTROL) CAME ON ALONG WITH SERVICE INDICATOR (WRENCH). I STOPPED AT SERVICE STATION AND WAS TOLD (AFTER A DIAGNOSTIC) THAT THE PROBLEM WAS RELATED TO THE ELECTRONICS IN THE THROTTLE CONTROL AND THAT IT WOULD NEED TO BE REPLACED . *TR

Feb 05, 2014

SAME AS A BUNCH OF COMPLAINTS ABOUT TRANSMISSION LUNGES HARD JOLT WHEN SHIFTING, WRENCH LIGHT COMES ON AND OFF REGARDING THE 2006 FORD EXPLORER, NOW THEY ARE TELLING ME THAT I NEED TO GET A NEW TRANSMISSION THAT WILL BE $3500.00 APROX. I HAVE DONE SOME RESEARCH AND THERE ARE A LOT OF COMPLAINTS ON THIS ISSUE. PLEASE DO SOMETHING!! I CAN'T AFFORD THIS AN HAVE TO BORROW FAMILY MONEY TO GET BACK ON THE ROAD. *TR

Jul 28, 2013

2006 FORD EXPLORER SPORADICALLY DOES NOT SPEED UP WHEN YOU HIT THE ACCELERATOR. FORD APPARENTLY KNOWS ABOUT THIS ISSUE AND HAS A SOFTWARE FIX IN PLACE THAT YOU MUST PROACTIVELY CONTACT THEM ON...IN OTHER WORDS, YOU HAVE TO HAVE THE PROBLEM ON THE ROAD AND CALL THEM BEFORE THEY WILL DO ANYTHING ABOUT IT. IT OCCURS EVERYTIME WE DRIVE THE CAR, HOWEVER, IT IS NOT CONSISTENT WHEN IT OCCURS OR HOW OFTEN...AT TIMES IT HAPPENS THE ENTIRE TIME THE CAR IS BEING DRIVEN. THE CONSEQUENCES ARE THAT YOU CAN BE DRIVING 10MPH OR 70MPH AND WHEN YOU HIT THE ACCELERATOR, THE CAR ENGINE WILL REV UP MUCH LIKE YOU WERE SITTING IN NEUTRAL (I.E. IT DOES NOT SPEED UP) AND AFTER A FEW SECONDS WILL KICK INTO GEAR/ENGAGE AND START SPEEDING UP. THIS SEEMS VERY DANGEROUS IF YOU WERE NOT EXPECTING THIS TO OCCUR AND WERE TRYING TO PASS A CAR WITH POSSIBLE ONCOMING TRAFFIC. THIS ISSUE SHOULD REQUIRE FORD TO RECALL THE VEHICLES BEFORE SOMEBODY GETS INJURED, IF THEY HAVE NOT ALREADY BEEN. *TR

Jul 27, 2009

+ 2 more complaints for this component

SERVICE BRAKES

6 complaints

TOOK THIS VEHICLE TO MY FORD DEALER WHERE I BOUGHT IT AND THEY PUT ON A NEW MASTER BRAKING CYCLINDER AND THE BRAKE PEDAL STILL GOES TO THE FLOOR. FORD DEALER DOES NOT KNOW WHERE THE PROBLEM IS TO BE ABLE TO FIX IT AND FORD MOTORS IS AWARE OF THIS PROBLEM AND DOING NOTHING ABOUT IT AT ALL.

Nov 01, 2015

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT HEARD A SOUND OUTSIDE THE VEHICLE AS IF TWO METAL OBJECTS WERE GRINDING AGAINST EACH OTHER. THE SERVICE WRENCH WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. IN ADDITION, THE 4-WHEEL DRIVE, TRACTION CONTROL, AND ABS WARNING INDICATORS ILLUMINATED CONTINUOUSLY AND THE BRAKES SEIZED. THE BRAKES RESUMED NORMAL OPERATION AFTER NUMEROUS ATTEMPTS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

Sep 15, 2014

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE BRAKES SEIZED. THERE WERE NO WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT SHUT OFF THE VEHICLE AND WAS ABLE TO RESTART IT FIVE MINUTES LATER. THE FAILURE OCCURRED ON FIVE DIFFERENT OCCASIONS. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN.

Jun 23, 2014

RETURNING FROM HAVING NEW BRAKES AND CALIPER INSTALLED - BRAKES WERE BURNING HOT AND STRONG SMELL. THIS HAS HAPPENED AGAIN AFTER AN HOUR DRIVE BUT NOT ON SHORTER DRIVES - BEEN TOLD THERE IS NO APPARENT PROBLEM I UNDERSTAND THAT THERE HAVE BEEN OTHER CONCERNS ABOUT BRAKES SEIZING UP ON EXPLORERS SO WANTED TO ADD MY CONCERNS TO THE POOL OF INFORMATION. *TR

Jun 23, 2014

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THE BRAKE PEDAL FAILED TO ENGAGE AND SUNK INTO THE FLOORBOARD. THE VEHICLE WAS TAKEN TO THE DEALER HOWEVER, THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE TECHNICIAN THEN RECOMMENDED HAVING THE BRAKE LINES BLED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 57,500.

Oct 18, 2013

+ 1 more complaint for this component

SEAT BELTS

5 complaints

TAKATA RECALL-2ND ROW PASSENGER SEAT BELT IS LOCKED UP. MY GRANDKIDS RIDE IN THIS AREA AND I DESPERATELY NEED TO GET THIS REPAIRED AND WANTED TO KNOW IF THIS IS AN ISSUE WITH ANYONE ELSE

Jun 24, 2018

I HAVE A 2006 FORD EXPLORER BOUGHT FOR THE AMOUNT OF SEATS. AFTER PURCHASED REALIZED ONE SEAT BUCKLE WAS BROKEN AND JUST TODAY ANOTHER BROKE. I BUCKLED MY CHILD'S CAR SEAT, GOT ON THE ROAD AND IT WAS UNBUCKLED. TRIED TO REBUCKLE IT AND THE BUCKLE WOULD NOT HOLD. TOTAL SAFETY ISSUE!! *TR

Jun 19, 2010

MY DAUGHTER GOT TANGLED IN THE SEATBELT. NORMALLY THAT WOULD NOT BE A PROBLEM BUT SHE HAD PULLED THE SEAT BELT ALL THE WAY OUT AND ACTIVATED THE LOCKING MECHANISM. IT WAS VERY TIGHT AROUND HER WAIST AND I COULD NOT GET HER FREE FROM THE SEAT BELT. I HAD TO CUT IT IN ORDER TO FREE HER. I HAVE HAD TO TAKE HER TO THE DOCTOR BECAUSE OF SOME INJURY TO HER. I FEEL THERE SHOULD BE SOME KIND OF RELEASE ON THE SEATBELT LOCK. I AM SO THANKFUL SHE WAS NOT HURT ANY WORSE THAN SHE WAS. I CANNOT BELIEVE IT IS GOING TO COST ME SO MUCH TO REPLACE A SEAT BELT THAT I HAD NO CHOICE BUT TO CUT. I HOPE TO SEE SOMETHING DONE ABOUT SEATBELTS SO NO ONE HAS TO GO THROUGH THIS. *TR

May 10, 2008

Injuries: 1

TL*THE CONTACT OWNS A 2006 FORD EXPLORER. WHILE DRIVING 40 MPH, THE REAR SEAT BELT BUCKLE LOOSENED WITHOUT WARNING. THE CHILD SITTING IN THE BOOSTER SEAT SLAMMED HIS FACE AGAINST THE SEAT IN FRONT OF HIM, LEAVING A SLIGHT BURN ON HIS NOSE. THE ROAD CONDITIONS WERE DRY. THE VEHICLE IS CURRENTLY AT THE CONTACT'S RESIDENCE AND HAS NOT BEEN TAKEN TO A REPAIR SHOP. THE POWERTRAIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 18,200.

Jul 25, 2007

Injuries: 1

THE PASSENGER FRONT SEAT LAP AND SHOULDER BELT ASSEMBLY LOCKS UP FOR NO APPARENT REASON WHENEVER A PERSON SITS IN THIS SEAT.

Mar 19, 2007

WHEELS

5 complaints

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THE REAR DRIVER SIDE TIRE DETACHED FROM THE VEHICLE, WHILE DRIVING APPROXIMATELY 30 MPH. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE WHEEL BEARING ASSEMBLY AND THE ROTOR ASSEMBLY NEEDED TO BE REPLACED. IN ADDITION, THE LUG NUTS WERE LOOSE. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 118,000.

Sep 12, 2016

THE WHEELS ARE DISINTEGRATING AND EST SENSORY HAD TO BE REPLACED. ALSO ABOUT FOUR YEARS AGO THE CAR WOULD STOP RUNNING IN TRAFFIC AND IT TOOK ABOUT A MONTH TO FIND PROBLEM AND WAS VERY COSTLY. *TR

Jul 14, 2014

SHARP BANG IN THE REAR FOLLOWED A FEW MINUTES LATER BY ANOTHER SHARP BANG. THOUGHT POSSIBLE CONTACT BETWEEN FRAME AN EXHAUST SYSTEM. CONTINUED DRIVING. AFTER ANOTHER 4-5 MILES NOTED FEELING IN CAR OF SLIGHT TRAMPING ON DECELERATION. CONTINUED TRAMPING ON DECELERATION AND INCREASED MORE NOTICEABLE IN RIGHT TURNS, BECAME LOUDER VIBRATION THROUGH BODY DETERMINED PROBLEM IN LEFT REAR. STOPPED CAR EXAMINED LEFT REAR WHEEL. TWO WHEEL BOLTS BROKEN, REMAINING THREE WHEEL NUTS LOOSE WITHIN A FEW TURNS OF COMING OFF. HAD DRIVEN APPROXIMATELY 13 MILES SINCE INITIAL BANG AT SPEEDS OF 30-40 MPH. FEEL VERY FORTUNATE THAT WHEEL HAD NOT COME OFF AND I WAS NOT ON A FREEWAY. *TR

Dec 05, 2012

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT WHILE ACCELERATING FROM A TRAFFIC STOP, A LOUD NOISE WAS HEARD FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSED THAT THE LUG NUTS HAD SHEARED, CAUSING THE WHEEL TO DETACH FROM THE VEHICLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VIN WAS NOT AVAILABLE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 95,000 AND THE CURRENT MILEAGE WAS 96,000.

Dec 14, 2011

ON OUR 2006 FORD POLICE EXPLORES, THERE HAVE BEEN 7 TO 10 WHEEL SEPARATIONS ON OUR VEHICLES, HAS THERE BEEN AN INVESTIGATION ON THIS ISSUE. AND DOES FORD USE THE RECALL WHEELS OFF OF THE CROWN VIC'S AND CROSS OVER TO THE EXPLORERS? THANK YOU MARK ORENDORFF *TR

Sep 26, 2008

Crash: 1

ENGINE AND ENGINE COOLING,EQUIPMENT

5 complaints

DEVELOPING COOLANT LEAK BELOW FORD EXPLORER 2006 RADIATOR. MY MECHANIC HAS DECLARED THE RADIATOR DEFECTIVE AND IS FAILING. THIS IS THE SECOND FAILED RADIATOR. THE FIRST FAIL WAS IN OCT 2009, APROX 48K MILEAGE, AND WAS CONSIDERED A PROBLEM KNOWN BY FORD. NOW I FACE A SECOND REPLACEMENT OF EXCESS $800 ESTIMATE MARCH 24TH 2011. MY ESTIMATED MILEAGE WAS 24K BETWEEN REPAIRS. THIS NEEDS TO BE SOLVED OR OUR FUTURE CARS WILL NEVER BE FORD! *TR

Mar 24, 2011

2006 FORD EXPLORER - 62,000 MILES AND I AM ON RADIATOR #5 - MANUFACTURER AND DEALER WILL NOT DO ANYTHING TO HELP - STATING IT IS NOT UNDER WARRANTY AND I DID NOT BY EXTENDED WARRANTY 1/2007 PURCHASED VEHICLE - 10/2007 28,000 MILES REPLACED RADIATOR - DEALER COST UNDER WARRANTY 3/2009 45,000 MILES REPLACED RADIATOR AGAIN - MY COST - NOT UNDER WARRANTY 10/2009 54,500 MILES REPLACED RADIATOR AGAIN . DEALER PD INDEPENDANT GARAGE - MARCH RADIATOR WAS UNDER WARRANTY. 5/10- REPLACED RADIATOR AGAIN - RADIATOR UNDER WARRANTY - BUT LABOR WAS MY COST ... *TR

May 15, 2010

RADIATOR LEAK IN 2006 FORD EXPLORER. V6 ENGINE. HAPPENED AT 42,000 MILES. HAPPENED A SECOND TIME ON 4/11/10. *TR

Apr 12, 2010

I BELIEVE THE FORD EXPLORER 2006 RADIATORS NEED TO BE RECALLED! FIRST OF ALL, LET ME JUST SAY THAT ON CARCOMPLAINTS.COM THERE ARE 47 COMPLAINTS ABOUT RADIATOR LEAKS AND HAVING TO REPLACE RADIATORS. I BELIEVE THIS TO BE A SAFETY ISSUE BECAUSE IF IT OVERHEATS...IT COULD LEAVE SOMEONE STRANDED ON SIDE THE HIGHWAY, OR EVEN EXPLODE OR CATCH ON FIRE! PLEASE LOOK AT CARCOMLAINTS.COM AND REVIEW THE COMPLAINTS ABOUT FORD 2006 EXPLORER RADIATORS! MANY PEOPLE HAVE GOTTEN THIS SAME RADIATOR REPLACED MORE THAN ONCE! OK, NOW TO ME...I BOUGHT A 2006 FORD EXPLORER IN JANUARY OF 2006. IN MARCH OF 2008, I WAS TOLD THAT MY RADIATOR NEEDED TO BE REPLACED. I COULDN'T UNDERSTAND WHY A VEHICLE WITH 40,000 MILES ON IT, WHICH GET SCHEDULED MAINTENANCE CHECKS REGULARLY WITH A MECHANIC COULD HAVE SUCH A PROBLEM. WELL, NEEDLESS TO SAY...I GOT IT REPAIRED OUT OF POCKET BECAUSE MY 36,000 MILE WARRANTY HAD EXPIRED. IT WAS VERY COSTLY. WELL,I CONTINUED TO GET MY VEHICLE MAINTENANCE AS SCHEDULED. WELL, JUST A COUPLE OF DAYS AGO OR LESS THAN 23 MONTHS(LESS THAN 2 YEARS) LATER, I EXPERIENCE THE SAME PROBLEM. ANOTHER RADIATOR LEAK! I HARDLY EVEN GO ANY WHERE! THE NEW RADIATOR WAS YET AGAIN ANOTHER FORD RADIATOR! I COULD HAVE BEEN LEFT ON SIDE THE ROAD OR HAD SOME SORT OF EXPLOSION! I BELIEVE THERE ARE DEFECTS IN THESE RADIATORS AND I BELIEVE THAT FORD MOTOR COMPANY IS ISSUING OUT FAULTY EQUIPMENT. I BELIEVE THAT WE, THE CONSUMER, OR SUFFERING THE CONSEQUENCES DUE TO THEIR NEED TO STAY AFLOAT. AFTERALL, THEY TOO NEEDED A BAILOUT AND WHAT AGREAT WAY TO SAVE MONEY IF RADIATORS OR BUILTTO LAST ONLY A SHORT TIME,AND PEOPLE GO TO KEEP PAYING FOR NEW ONES! PLEASE CHECK ON THIS. I BELIEVE A RECALL IS NEEDED!!!!!!!! P.S. WHILE WRITING THIS LETTER, JUST RECEIVED A PHONE CALL THAT A TECHNICAL ALERT HAS BEEN PUT OUT ON 2006 FORD EXPLORER RADIATORS, AND BECAUSE OF THE COMPLAINT ...THE MODEL IS NOT BEING MADE ANYMORE! PLEASE CHECK INTO THIS! *TR

Feb 15, 2010

HAD A RADIATOR FAILURE THE FIRST YEAR. HAD A SECOND RADIATOR FAILURE 36,000 MILES LATER IN THE SAME SPOT ON THE SAME STYLE RADIATOR. LOOKING AT THE COMPLAINTS ON ONE OF THE FORD CHAT BOARDS IT LOOKS LIKE THERE ARE HUNDREDS OF US WITH THE SAME PROBLEM FROM 2006. DEALER ADMITTED THEY KNEW OF THE PROBLEM BUT THAT REPLACEMENT WAS NOT YET COVERED BY FORD AND THE RADIATORS WERE CURRENTLY ON BACK ORDER DUE TO HEAVY DEMAND. *TR

Apr 20, 2009

AIR BAGS

4 complaints

MY CHECK ENGINE LIGHT CAME ON. I STOPPED TO HAVE THE PARTS STORE GET THE CODES IT WAS THROWING OUT. TWO OF THE CODES HAVE TO DO WITH THE AIR BAG HAVING A MALFUNCTION IN THE SYSTEM. NEED TO KNOW IF THIS IS A MANUFACTURING ISSUE. I HAVE KIDS THAT RIDE IN THE VEHICLE SO TRYING TO TAKE PRECAUTIONS. THE CODES ARE B1884 AND B2290.

Nov 29, 2018

THE DASHBOARD ON THE PASSENGER SIDE IS STARTING TO MELT -VERY STICKY TO TOUCH.

Nov 04, 2015

NHTSA CASE # [XXX] JUST KNOW I REALIZE WHAT IS THE PROBLEM; IT IS RELATED WITH WEATHER TEMPERATURE. BEGINNING WINTER THE AIRBAG SOMETIMES LIT.. WHEN TEMPERATURE DROPPED, LIT CONTINUOUS, SO, I REPORTED FORD CUSTOMER RELATIONSHIP. (AT THAT TIME I HAD NO IDEA THAT THE FAILURE WAS LINKED TO TEMPERATURE}. WHEN TEMPERATURE BEGAN INCREASING, AGAIN AIRBAG LIT SOMETIMES. NOW THAT WEATHER IS GOOD, THE AIRBAG LIGHT IS NORMAL OK. MY CAR'S AIRBAG IS AT RISK AT LOW TEMPERATURES. HOW THIS IS A SAFETY ISSUE, I WANT FORD FIX IT. THANKS [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Apr 13, 2015

AT START UP IN COLD WEATHER THE AIR BAG WARNING LIGHT GLOWED ON DASH AND STAYED ON UNTIL NEXT START UP WHEN ENGINE WAS WARM IT HAPPENED A LOT BUT IS FINE IN WARM WEATHER. *TR

Jun 24, 2014

STEERING

4 complaints

WHILE PARKED, LOOKING FROM FRONT OF VEHICLE, I OBSERVED A METAL PART HANGING DOWN ON FRONT RIGHT UNDERSIDE NEXT TO INSIDE OF TIRE. AN ASE MECHANIC FRIEND SAW IT & KNEW THAT IT WAS A CORRODED STEERING STABILIZER LINK (LONG BOLT W/ GROMMETS). HE REACHED UNDER THE VEHICLE AND EASILY PULLED IT DOWN. HE SAID IT IS A COMMON PROBLEM ON MANY TYPES OF VEHICLES AND REPLACEMENT PART OF SLIGHTLY DIFFERENT DESIGN IS $10-20 & EASILY INSTALLED. I CALLED METRO FORD MADISON, WI WHO ADVISED THERE WAS NO RECALL ON THIS PART AND WOULD COST $200 TO INSTALL A NEW ONE PLUS REPLACE THE OTHER SIDE BUT NO WHEEL ALIGNMENT IS NEEDED. I DECIDED TO BUY 2 NEW LINKS (MOOG BRAND) THAT ARE A HEAVIER DESIGN AND MY SON & I INSTALLED THEM. THERE IS NOW MUCH LESS BODY ROLL ESPECIALLY NOTICE WHEN IN ROUND-A-BOUTS WHERE PREVIOUSLY WAS DIFFICULT TO REMAIN IN ONLY ONE OF THE 2 CIRCULAR LANES.

Jul 01, 2015

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED AFTER STARTING THE VEHICLE, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS WHERE THE CONTACT WAS INFORMED THAT DUE TO SEVERE CORROSION OF THE LOWER INTERMEDIATE SHAFT, THE COMPONENT WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 35,000. UPDATED 11/30/13*CN

Sep 20, 2013

I BOUGHT A FORD EXPLORER HYBRID LAST YEAR AND IT HAS ABOUT 2,000 MILES ON IT. ANYWAYS, I WAS DRIVING IT YESTERDAY TO WORK AND I WAS IN THE PASSING LANE MOVING TO THE RIGHT TURN LANE, AND AS I WAS DOING SO THE STEERING WHEEL LOCKED LIKE IT DID IT WHEN THE KEY WAS OUT. I SLAMMED ON THE BRAKES JUST BEFORE I HEADED STRAIGHT INTO THE LOCAL CVS. I TOOK THE CAR TO THE DEALER, AND THEY PERFORMED THE COMPUTER DIAGNOSTIC, BUT NOTHING CAME UP. I KNEW STEERING WHEELS WERE SUPPOSED TO LOCK UP WHEN DRIVING, SO BEFORE ANYONE DIED BECAUSE OF THIS, I DECIDED TO BRING IT TO YOUR ATTENTION.*AK

May 26, 2007

MY FORD EXPLORER XLT 2006 HAD A DELAYED DELIVERY DATE TO ME FOR 2 DAYS DUE TO A "BAD CLUSTER" ON START UP. THE TRUCK WAS REPAIRED AND I PICKED IT UP ON NOVEMBER 1, 2005. THIS VEHICLE IS LEASED. THERE WAS A RECALL FOR THE WINDSHIELD WIPERS WHICH I HAD REPAIRED ON DECEMBER 8, 2005. ON DECEMBER 9, 2005 WHILE I WAS DRIVING WITH MY TWO YOUNG CHILDREN IN THE TRUCK I PULLED OUT OF A PARALLEL PARKING SPACE AND THE STEERING WHEEL BEGAN TO FEEL VERY TIGHT AND IT WAS GRINDING WHEN STEERING SLIGHTLY LEFT OR RIGHT OF THE CENTER AND THEN IT WOULD FREE UP AGAIN MAKING THE TRUCK EASY TO OVERSTEER. AS I DROVE THE TIGHTNESS WOULD GO AWAY UNTIL I SLOWED DOWN AND THEN IT WOULD GET TIGHT AGAIN. ALSO THE GRINDING ON TURNS EITHER LEFT OR RIGHT REMAINED. I GOT TO A SAFE PLACE AND CALLED MY PURCHASING DEALER BURNS FORD 359 WEST JERICHO TPKE, HUNTINGTON, NY 11743. THEY ADVISED ME NOT TO DRIVE THE TRUCK AND CALL FORD ROADSIDE ASSISTANCE. I DID AND THEY TOWED THE TRUCK TO BURNS FORD. THEY CALLED ME LATER IN THE DAY TO TELL ME THAT FORD ADVISED THEM THAT THERE IS A PROBLEM WITH THE TRUCK AND PARTS WILL NOT BE AVAILABLE UNTIL THE 1ST QUARTER OF 2006. THE FOLLOWING IS THE NOTICE: 18962 2006 EXPLORER 4DR /MERCURY MOUNTAINEER-INTERMEDIATE (1) SHAFT POP/CLUNK NOISE. SOME 2006 EXPLORER 4DR AND MOUNTAINEER VEHICLES MAY EXHIBIT A CREAK/POP HEARD AND FELT THROUGH THE STEERING WHEEL, USUALLY NOTICED AT STATIONARY OF LOW-SPEED TURNS WHILE ACCELERATING AND BRAKING. IF DIAGNOSIS FINDS THAT THIS MAY BE DUE TO INTERMEDIATE SHAFT HAVING STICK-SLIP CONDITION, DO NOT REPLACE THE 1 SHAFT AT THIS TIME. THIS IS CURRENTLY UNDER INVESTIGATION BY ENGINEERING. A REVISED COMPONENT IS DUE FIRST QUARTER 2006. MONITOR OASIS FOR UPDATES. EFFECTIVE DATE: 12/1/2005. RIGHT NOW MY TRUCK IS STILL AT THE DEALER. I DO NOT FEEL COMFORTABLE DRIVING IT AND I NEED TO RENT A CAR. PLEASE ADVISE THANK YOU, LAURA MASIAKOS. *NM *AK

Dec 19, 2005

VISIBILITY,STRUCTURE

4 complaints

THIS HAPPENED TO OUR 2006 FORD EXPLORER (EDDIE BAUER EDITION, V8 4WD). THE REAR LIFTGATE GLASS EXPLODED INTO A MILLION TINY PIECES WITH NO EVIDENCE OF EXTERNAL TRAUMA. THE CAR WAS PARKED IN THE DRIVEWAY AT THE TIME AND THE TEMPERATURE WAS ABOVE FREEZING (LOW 40S) AND IT WAS NOT IN THE SUN. APPROXIMATELY HALF THE GLASS WAS SCATTERED ACROSS THE DRIVEWAY - 10+ FEET AWAY. THE REST OF THE GLASS WAS IN THE BACK OF THE SUV. FORTUNATELY NO ONE WAS AROUND WHEN THIS HAPPENED - AND WE WERE NOT DRIVING THE CAR AT THE TIME. THIS COULD HAVE RESULTED IN SERIOUS INJURY TO A BYSTANDER - OR AN ACCIDENT AS I CAN ONLY IMAGINE HOW MUCH THAT WOULD ALARM THE DRIVER. I WILL BE CLEANING GLASS BITS FROM THE DRIVEWAY AND BACK OF THE SUV FOR A LONG TIME TO COME! AT LEAST IT IS NOT TOO WARM OUT SO NO IS TEMPTED TO WALK BAREFOOT ON THE DRIVE. *TR

Apr 07, 2014

WAS DRIVING WHEN TILT GATE GLASS AJAR WARNING CAME ON, AT THE SAME TIME HEARD A WHISTLING NOISE. UPON STOPPING NOTICED THE LIFT GATE WAS AJAR WITH AND AWAY FROM THE HATCH BY SEVERAL INCHES. TIED TO CLOSE IT AND IT DID NOT CLOSE PROPERLY UPON INSPECTION THE HINGE WAS BROKE THAT HOLDS THE GLASS TO THE VEHICLE. MANAGED TO GET THE GLASS SOMEWHAT BACK IN PLACE AND DROVE GINGERLY HOME ALL WHILE THE LIFT GATE AJAR LIGHT WAS ON. THERE IS A LOT OF WHITE RESIDUE PACKED IN PART OF THE HINGE NOT KNOWN IF IT IS ROAD SALT OR NOT AND THE HINGE HAS A CRACK WHERE IT SEPARATED. MY CONCERN IS THE FAILURE IS RELATED TO SALT AND FREEZING AND THAWING, AND IF THAT IS THE CASE HOW LONG BEFORE THE OTHER ONE FAILS... ALSO IF DRIVING AT HIGHWAY SPEEDS WITH WINDOWS OPENED COULD IT HAVE CAUSED THE GLASS TO SHATTER SCARING THE DRIVER OF OTHER TRAFFIC CAUSING AN ACCIDENT. I HAVE CONTACTED FORD ABOUT IT IN CASE THEY WANTED TO SEE IT AND GOT THE NORMAL BASIC REPLY CAR IS OUT OF WARRANTY AND BASICALLY WE DON'T' CARE AT THIS TIME. *TR

Jan 27, 2012

VEHICLE ACCIDENT TWO OCCUPANTS BOTH HAD SEATBELTS ON, BOTH HAD AIRBAG DEPLOYED AND BOTH STILL STRUCK WINDSHIELD. ACCIDENT OCCURRED IN NOVEMBER AND AS OF MAY ONE OCCUPANT IS STILL REMOVING GLASS FROM ARMS AND LEGS. FORD WILL NOT RESPOND TO E-MAILS REQUESTING WHY SEATBELT AND AIRBAGS DID NOT PREVENT OCCUPANTS FROM STRIKING WINDSHIELD. *TR

May 14, 2008

Crash: 1

Injuries: 2

DT*: THE CONTACT STATED THERE IS A SEVERE WINDSHIELD GLARE COMING FROM THE DASHBOARD. THE DEALER INSPECTED THE VEHICLE AND DETERMINED THE VEHICLE FUNCTIONS PROPERLY. UPDATED 5/10/2006 - THE DASHBOARD REFLECTED ONTO THE WINDSHIELD AND COVERED ABOUT 70% OF THE WINDSHIELD. *NM

Apr 11, 2006

EQUIPMENT

4 complaints

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. WHILE DRIVING A TIRE BLEW-OUT. WHEN CHANGING THE TIRE, THE JACK FAILED. A TECHNICIAN FROM THE DEALER STATED THAT THEY ARE GOING TO SELL HIM ANOTHER JACK. HE WAS THEN ADVISED THAT THIS WAS A COMMON FAILURE FOR HIS MODEL TYPE. THE FAILURE MILEAGE WAS 83000. THE CURRENT MILEAGE WAS 83137.

Dec 31, 2009

AC PROBLEM- I BOUGHT MY 06 EDDIE BAUER EXPLORER WITH A LITTLE OVER 5000 MILES. THE AC WAS MAKING A SCREECHING NOISE THEN. TOOK MY SUV BACK TO THE DEALER WHERE IT WAS PURCHASED, THEY STATED THEY RAN THE AC FOR 15-20 MINS. AND DID NOT HEAR THE NOISE. NOW ACCORDING TO THE SERVICE SHOP WHERE MY SUV HAS BEEN FOR 3 WEEKS, MY AC (COMPRESSOR) COMPLETELY FELL APART. NOT ONLY THAT, THE PARTS ARE ON BACK ORDER. I HARDLY EVER USE MY AC. IF I DID, I GUESS IT WOULD OF FELL APART SOONER. ANYHOW, MY SUV IS ONLY A 2006 AND AS I SAID I HARDLY EVER USE THE AC. NOT ONLY THAT, THE PARTS ARE ON BACK ORDER. WHICH MEANS I AM NOT THE ONLY ONE HAVING THIS PROBLEM. FORD NEEDS TO ISSUE A RECALL. *TR

Aug 20, 2008

TL*THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT WHEN SHE TURNED HER HEAT ON IN THE VEHICLE IT WENT FROM HOT AIR TO COLD. SHE TRIED SEVERAL TIMES TO TURN IT ON AND OFF HOPING TO RESET IT, BUT ONLY COLD AIR WOULD COME THROUGH THE VENTS. ONCE THE CAR WAS PARKED SHE NOTICED A LEAK FROM UNDER THE CAR. SHE TOOK THE VEHICLE TO A LOCAL MECHANIC AND THEY DIAGNOSED THE PROBLEM AS A RADIATOR LEAK. SHE THEN CONTACTED THE DEALERSHIPS AND INFORMED THEM OF THE PROBLEM, THEY INFORMED HER THAT THE PART WAS ON BACK ORDER AND IF SHE REPAIRED IT AT ANY LOCAL MECHANIC IT WOULD VOID THE WARRANTY. THE DEALER ADVISED HER NOT TO DRIVE THE CAR, IT IS PARKED AND HAS NOT BEEN REPAIRED AT THIS TIME. THE FAILURE MILEAGE 50,000 AND CURRENT MILEAGE WAS 51,000.

May 30, 2008

I HAVE A 2006 FORD EXPLORER THAT THE AIR CONDITIONER QUIT WORKING. IT HAD ONLY 5,700 MILES ON IT. I WAS TOLD THAT THE "O" RINGS ON THE AC COMPRESSOR WERE LEAKING. HAVING THE AC GO OUT ON A NEW VEHICLE WITH SUCH LOW MILES MAKES YOU THINK ABOUT THE QUALITY (OR LACK OF) IN THIS VEHICLE. *TR

Jul 25, 2007

VEHICLE SPEED CONTROL,ENGINE

3 complaints

DRIVING ON SPEED LIMIT I STOPPED AT A LIGHT, CAR ENGINE WENT DEAD. I TURNED KEY OFF AND WAITED A FEW MINUTES, TURNED KEY ON, CAR STARTED AS NOTHING WAS WRONG. IT HAS HAPPENED 3 TIMES IN THE PAST YEAR. BATTERY AND ALTERNATOR ARE PRETTY NEW. DECIDED TO TAKE TO AN AUTHORIZED MECHANIC DEALER, COULDN'T FIND ANYTHING WRONG WITH THE ENGINE. REALLY? WHAT IF I WAS DRIVING IN A HIGHWAY? CERTAINLY I WOULDN'T BE ALIVE TO REPORT IT!

Feb 23, 2021

WHILE TRAVELING ON THE HIGHWAY THE VEHICLE SUDDENLY LOST POWER AS IF IT STALLED. ENGINE WAS RUNNING BUT VEHICLE HAD NO POWER. VEHICLE HAD TO BE TURNED OFF AND RESTARTED TO REGAIN POWER. ALWAYS FEARED BEING REAR ENDED OR STALLING ON RAILROAD TRACKS. DEALER DETERMINED IT WAS ELECTRONIC THROTTLE CONTROL AND REPLACED IT. THE VEHICLE HAS NOT HAD THIS MALFUNCTION SINCE THE REPAIR ABOUT 18 MONTHS AGO. *TR

Mar 08, 2014

THE VEHICLE WAS DRIVING AT A SPEED OF 40-45 MPH AND STALLED. THIS AGAIN HAPPENED ON MAY 25, 2012 WHILE LEAVING ON OUR VACATION. WE PARKED THE VEHICLE AND RENTED ONE TO DRIVE THE REMAINING DISTANCE. WHEN TAKEN TO A MECHANIC IT WAS FOUND THE THROTTLE BODY WAS BAD. WE HAVE REPLACED IT AND IN THE MONTH OF NOVEMBER THE VEHICLE BEGAN DOING IT AGAIN. AS YOU DRIVE IT WILL JUST COMPLETELY SHUT OFF. AS THE MECHANIC TOLD US THERE IS NO ELECTRICITY GOING TO THE ENGINE AND YOU CAN COAST TO THE SHOULDER AND RESTART THE VEHICLE. THIS WILL BE THE 2ND TIME CORRECTING THIS PROBLEM IF THIS IS THE TRUE ISSUE. IT WAS READ THERE IS A RECALL ON FORD VEHICLES FOR THAT YEAR MAKE BUT NOT FOR THE EXPLORER MODEL. I HAVE CONTACTED FORD AND THEY ALSO STATED THERE IS NO RECALL. WITH THE AGE AND LOW MILEAGE OF THE VEHICLE THERE IS NO REASON THIS SHOULD BE HAPPENING. *TR

Feb 27, 2013

FUEL/PROPULSION SYSTEM

3 complaints

ON MY 2006 EXPLORER I AM UNABLE TO FILL THE TANK WITH GASOLINE. IT ALMOST IMMEDIATELY BACKS UP THE FILL TUBE AND TURNS THE FUEL PUMP OFF. IT'S BEEN TO MANY MECHANICS WHO HAVE TOLD ME THAT THE PROBLEM IS WITH THE FUEL TANK ITSELF. THEY HAVE SAID THAT IT SHOULD HAVE BEEN A RECALL ON FORD'S PART LONG AGO. BECAUSE OF THIS PROBLEM I WILL BE UNABLE TO PASS EMISSIONS TEST BECAUSE THE VEHICLE IS SENSING A FUEL VAPOR LEAK. ALSO I HAVE SEARCHED THE INTERNET FAR AND WIDE AND FOUND MANY PEOPLE WHO SAY THEY HAVE THE SAME PROBLEM. THEY HAVE BROUGHT THEIR VEHICLES SPECIFICALLY TO FORD DEALERSHIPS WHO HAVE CHARGED THEM MONEY TO REPLACE PARTS THAT DID NOT FIX THE ISSUE WHAT SO EVER. PLEASE LOOK FURTHER INTO THIS PROBLEM. ON BEHALF OF MANY OTHERS AND MYSELF, THANK YOU FOR YOUR TIME!

Jul 28, 2017

FORD HAS KNOWN ABOUT FUEL TANK FILLING ISSUES SINCE THEY ISSUED AN INTERNAL TSB IN 2007. PROBLEM CAUSES FUEL TANK TO FILL WITH PRESSURE, AND NOT ACCEPT FUEL. AS A RESULT, FUEL IS SPRAYED ALL OVER VEHICLE AND THE PERSON FUELING VEHICLE. WE HAD VEHICLE IN FOR REPAIRS NUMEROUS TIMES, AND STILL HAVING FUEL TANK ISSUES. THERE ARE "UNCOUNTABLE" NUMBERS OF FORD EXPLORER OWNERS THAT I HAVE FOUND ON THE INTERNET, THAT HAVE THIS PROBLEM, AND THEY DO NOT KNOW THAT FORD KNOWS THE REASON FOR THIS FAILURE. FORD SHOULD HAVE ISSUES A RECALL NOTICE TO PROTECT DANGER OF FUEL SPRAY. *TR

May 12, 2013

MY 2006 FORD EXPLORER IS RANDOMLY ACCELERATING AND STALLING. I AM ON THE ROAD ALOT AND IT HAS ALMOST CAUSED A FEW ACCIDENTS. THE ENGINE LIGHT AND WRENCH LIGHT COMES ON BUT RESETS ITSELF. IT JUST HAPPENED AGAIN TODAY AND I WAS INFRONT OF AN AUTO ZONE. I STOPPED IN AND LEFT THE CAR RUNNING. I HAD THE ASSOCIATE COME OUT TO TEST IT AND THE CAR WAS STALLED. HE TESTED IT AND IT HAD 5 CODES ALL OF THEM RELATING TO THE THROTTLE POSITION SENSOR. SO I GOT HOME LOOKED ONLINE AND LOW AND BEHOLD THERE ARE A WHOLE SLEW OF COMPLAINTS ON THE NET ABOUT PEOPLE HAVING THIS SAME PROBLEM. THIS IS NOT SAFE. I WILL HAVE IT FIXED NOW THAT I NARROWED DOWN THE PROBLEM BUT THIS WILL KILL SOMEONE. SEEMS LIKE THAT'S WHAT IT TAKES BEFORE ANYONE CARES. *TR

Oct 25, 2012

STRUCTURE

3 complaints

WHILE DRIVING THE LIFT GATE OPENS ON IT'S OWN. *TR

Jul 06, 2012

TL*- THE CONTACT BOUGHT THE 2006 FORD EXPLORER SOMETIMES DURING THE END ON JANUARY 2007 AND IT HAS HAD EXCESSIVE RUST UNDER THE DRIVER'S SEAT, THE PASSENGER'S SEAT, AND THE STEERING COLUMN , ALSO IT LEAKED WHEN RAINING FROM THE WINDSHIELD AND OVERHEAD LIGHT. THE ENTIRE TRUCK GOT WET. THE TRUCK SHOOK BADLY ,AND THE TIRE LIGHT TURNED ON BECAUSE OF THE SHAKING. THE DEALER STATED THIS WAS TYPICAL OF THIS TYPE TRUCKS TO HAVE ALL THIS RUST ON THEM, AND THEY WILL NOT TAKE CARE OF THE PROBLEM OR TAKE IT BACK. THE FAILURE MILEAGE WAS 20190, AND THE CURRENT MILEAGE WAS 21000.*AK

Feb 26, 2007

FUEL LEVEL AND ENGINE TEMPERATURE GAUGES ARE ALMOST IMPOSSIBLE TO READ IN DAYLIGHT, REQUIRING A DRIVER TO TAKE HIS/HER EYES FROM THE ROAD FOR AN EXCESSIVE PERIOD OF TIME. THIS CREATES A POTENTIALLY DANGEROUS SITUATION WHILE DRIVING A 2006 FORD EXPLORER. *JB

Apr 11, 2006

TIRES

2 complaints

TL* THE CONTACT OWNS A 2006 FORD EXPLORER EQUIPPED WITH MICHELIN LATITUDE TOUR GREEN X TIRES, SIZE: P245/65R17. THE CONTACT STATED THAT AREA WHERE THE TREAD MET THE SIDEWALL WAS SEPARATING. THE FAILURE WAS EVIDENT ON ALL FOUR TIRES. THE CONTACT HAD TO REPLACE ALL FOUR TIRES ON 8/29/2014 FOR THE SAME FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE TIRES WERE NOT REPLACED AGAIN. THE TIRE AND VEHICLE FAILURE MILEAGE WAS 106,930.

May 04, 2016

TL*THE CONTACT OWNS A 2006 FORD EXPLORER. SHE PURCHASED FOUR TIRES THIRTEEN MONTHS AGO AND THEY ARE APPROXIMATELY FIFTY PERCENT WORN. THE TIRES ARE GOODYEAR MODEL#FORTERA-HL, SIZE 245/65R17. THE GOODYEAR MANUFACTURER STATED THAT THEY WOULD REPLACE THE TIRES AT A PRORATED PRICE AT A FIFTY PERCENT DISCOUNT. SHE PREVIOUSLY PAID $600 AND NOW HAD TO PAY ANOTHER $300 FOR THE TIRES. THE FAILURE WAS 30,086 AND THE CURRENT MILEAGE IS 43,000. UPDATED 10/15/10 BF UPDATED 10/18/10*JB

Jul 20, 2010

POWER TRAIN,VEHICLE SPEED CONTROL

2 complaints

IT WOULD NOT SHIFT IN REVERSE TILL I TURNED IT OFF AND RESTART IT TOOK THE REVERSE. AFTER THE INCIDENT THE EXPLORER KEEP ON GIVING ME PROBLEMS EVERY TIME I'LL SHIFT IT INTO REVERSE. I HAVE TO ACTUALLY PUNCH THE GAS SO IT COULD GET THE REVERSE GEAR. IT HAS BEEN MANY TIMES THAT I HAD TO QUICKLY STEP ON THE BRAKES TO AVOID HITTING ON COMING TRAFFIC AS WELL AS PARKED CARS, AFTER HAVING TO PUNCH ON THE GAS SO I COULD GO IN REVERSE. I HAVE BEEN TOLD THAT IT COULD BE THE TRANSMISSION. *TR

Jul 05, 2014

THE TRUCK JOLTS WHEN SHIFTING GEARS TO REVERSE AND DRIVE, I FEELS LIKE A CAR RAN INTO ME FROM THE BACK. IT HAS CAUSED ME TO BUMP INTO ANOTHER CAR IN FRONT OF ME WHEN I WAS SITTING IN TRAFFIC, AS I ACCELERATE THE GAS PEDAL IT EITHER STALLS OR JOLTS VERY HARD, THANK GOD IT THERE WAS NO DAMAGE TO THE OTHER CAR NOR MINE. EVER SINCE THIS HAPPENED, IT HAS BEEN BIG PROBLEM WHEN DRIVING ON THE ROAD, AND NOW THE TRUCK DOESN'T PICK UP SPEED VERY QUICKLY EVER SINCE THIS HAPPENED, WHEN I GET TO 20 MPH IT STALLS OR JOLTS AFTER 3-5 SECONDS. MY SHIFT STICK IS ALL MESSED UP NOW, WHEN I PUT IT IN REVERSE, IT LOOKS LIKE ITS ON NEUTRAL AND PARK LOOKS LIKE ITS ON 3RD GEAR. SERVICE MECHANICS HAVE ALMOST CRASHED MY CAR BECAUSE OF THIS ISSUE, AND FORD HAS SAID THEY CAN'T GUARANTEE A PROPER REPAIR!! THEN WHY SELL IT IF YOU CAN'T REPAIR IT PROPERLY SO I WONT HAVE PROBLEMS IN THE FUTURE. THIS VEHICLE NEEDS TO BE RECALLED FOR SAFETY ISSUES. *TR

Aug 26, 2013

POWER TRAIN,STRUCTURE

2 complaints

MY 2006 FORD EXPLORER WAS PARKED IN THE DRIVEWAY. AT 4:30 IN THE MORNING IT ROLLED BACKWARDS OUT OF MY DRIVEWAY AND CRASHED INTO A FENCE ACROSS THE STREET. THE VEHICLE HAD BEEN IN PARK AND THE DOORS WERE LOCKED. MY NEIGHBORS HEARD THE CRASH, LOOKED OUT THEIR WINDOW AND RAN OUTSIDE. A CHAIN LINK FENCE AND VERY SMALL CONCRETE WALL STOPPED THE VEHICLE. LUCKILY THERE WAS NO ONE OUTSIDE OR ANY OTHER CARS. THERE IS SIGNIFICANT BODY DAMAGE TO MY EXPLORER AND THE LEFT REAR WHEEL IS PUSHED OUT. HOW DOES A VEHICLE ROLL ACROSS THE STREET WHILE IN PARK? EVEN IF THE VEHICLE IS OUT OF WARRANTY, SHOULDN'T THIS BE SOMETHING FORD WOULD BE RESPONSIBLE FOR? *TR

Jun 03, 2014

Crash: 1

I BOUGHT A 2006 FORD XLT EXPLORER WITH APX. 17,000 MILES. I HAD IT FOR ABOUT 3 MONTHS IT HAD ABOUT 19,000 MILES. I DRIVE IT ABOUT 100 MILES TO A CONVENTION AND BY THE TIME I GOT THERE AND PULLED INTO A PARKING LOT THE VEHICLE STARTED SHIFTING HARD, JERKING AND LUNGING. IT WAS MAKING A LOUD BANGING SOUND AND FELT LIKE THE TRANSMISSION WAS GOING TO FALL OUT. I TOOK IT TO FORD, THEY DID SOME WORK ON THE TRANSFER CASE AND REPLACED A MODULE. ABOUT A MONTH AND A THOUSAND MILES LATER, IT STARTED DOING IT AGAIN. TOOK IT BACK TO FORD AND THEY DID SOME MORE WORK. THE SHIFTER LEVER WAS REPLACED. LATER IT STARTED DOING IT AGAIN. I HAVE TAKEN IT BACK SEVERAL TIMES AND THE VEHICLE CONTINUES TO HAVE THE PROBLEM. IT DOESN'T DO IT EVERY DAY BUT DOES DO IT SEVERAL TIMES A WEEK, SOME DAYS ARE WORSE THAN OTHERS. AS TIME GOES BY IT SEEMS TO GET WORSE AND HAPPEN MORE OFTEN. SOMETIME WHEN I PUT THE VEHICLE IN REVERSE THERE IS A DELAY TO ENGAGE AND ONE MORNING IT CAUSE ME TO BACK INTO ANOTHER VEHICLE. IT ALSO HAS A CRACKED RUNNING BOARD. *TR

Jan 13, 2010

FUEL SYSTEM, GASOLINE,POWER TRAIN

2 complaints

ISSUE. HARD JERKS/CLUNKS WHILE SHIFTING INTO REVERSE AND THEM FORWARD. ALSO FEELS AS IF YOUR ARE BEING HIT IN BUMPER AS YOU ARE STOPPING WHILE TRANSMISSION IS DOWN SHIFTING. THIS SEEMS TO BE AN ON GOING ISSUE WITH SO MANY 2006 EXPLORERS, PLEASE LOOK INTO A RECALL AS THIS A DEFECT WITH THE FORD MODEL. ALSO WAY TOO EXPENSIVE FOR PARTS AND LABOR! FAILURE AT MILEAGE OF 81,800. TOO EARLY TO DIE WITH THIS MILEAGE! *TR

Aug 15, 2013

BOUGHT 2006 EXPLORER NEW. AROUND 14,000 MILES ENGINE PROBLEMS STARTED, HAVE TAKEN CAR IN TO FORD DEALER WHERE CAR WAS PURCHASED ABOUT 7 TIMES FOR BASICALLY SAME PROBLEM ~ ENGINE LIGHT / CAR ENGINE LUNGING . MECHANICS DID DIFFERENT THINGS; REPLACED ONE DEFECTED PART WHILE UNDER WARRANTY, RESET COMPUTER, BUT PROBLEM ALWAYS CAME BACK. SOMETIMES HAPPENING BEFORE I MADE IT HOME. SOME TIMES MONTHS LATER. NOW THEY THINK MAYBE IT COULD BE THE THROTTLE BODY. *TR

Feb 20, 2010

SERVICE BRAKES, HYDRAULIC,ELECTRICAL SYSTEM

2 complaints

THE WRENCH, THE ABS, AND THE ANTI-SWAY ICONS STARTED COMING ON INTERMITTENTLY ON MY 2006 EXPLORER. THEY WOULD RESET IMMEDIATELY USING THE RESET BUTTON. THE DEALER REPLACED A WHEEL-SPEED SENSOR AND STATED THAT THE SENSOR WAS DAMAGED WHEN THE "TONE" WHEEL CRACKED. DEALER ALSO STATED THAT UNLESS THE TONE WHEEL WAS REPLACED, THE ABS WAS NOT OPERATIONAL. THEY CHARGE ABOUT 200.00 FOR THE REPAIR. *TR

Apr 05, 2012

2006 FORD EXPLORER XLT WOULDN'T START DEALERSHIP REPLACED INSTRUMENT CLUSTER COST $544.00. STILL HESITATES TO START (TURN KEY NOTHING... NO CLICKING TAKES A FEW ATTEMPTS) TOOK BACK DEALERSHIP SAYS STARTER IS BAD. NOW ABS+TRACTION LIGHT +WRENCH LIGHT ON. TAKING BACK TOMORROW. HOW CAN ALL THESE PROBLEMS SURFACE AT ONCE AND NOT BE RELATED???? *TR

Feb 22, 2010

ENGINE AND ENGINE COOLING,VEHICLE SPEED CONTROL

2 complaints

THE VEHICLE HAS HARSH UPSHIFTS WHEN ACCELERATING FROM 1ST TO 4TH GEAR, CREATING MOMENTARY LOSS OF CONTROL. THE VEHICLE WILL STALL, THEN JERK FORWARD A FEW INCHES UNANNOUNCED, WHICH HAS THE POTENTIAL OF CAUSING A WRECK OR HITTING A PEDESTRIAN. THE SAME WILL OCCUR WHEN SHIFTING FROM DRIVE TO REVERSE, AND VICE-VERSA. ALSO, SOMETIMES THE RPM WILL INCREASE DRASTICALLY ON ITS OWN WITHOUT AN INCREASE IN SPEED. I'M AFRAID THIS WILL CAUSE AN ACCIDENT IF THE SPEED DECIDES TO INCREASE. *TR

Jan 07, 2012

VEHICLE HAS 1978 MILES, 2006 FORD EXPLORER, HAS MAJOR HESITATION IN THROTTLE, AFTER 3 TRIPS TO DEALER, THEY SAY VEHICLE CANNOT BE REPAIRED". THIS SUV IS UNSAFE TO DRIVE DUE TO THE HESITATION IN THE THROTTLE, CANNOT PULL INTO TRAFFIC, FROM STOP SIGN, OR FROM STOPPED POSITION. *JB

Aug 06, 2006

SUSPENSION

2 complaints

2006 FORD EXPLORER 60000 MILES. FRONT WHEEL BEARINGS NEED REPLACEMENT. NO OFFROAD, STREET DRIVING ONLY.

Jan 12, 2011

I HAVE HAD THE CONTROL ARMS BOLTS ON BOTH SIDES OF THE VEHICLE NOW LOOSENED UP SUFFICIENTLY ENOUGH TO CAUSE THE VEHICLE TO SWERVE SUDDENLY WHEN BRAKING. FORTUNATELY WAS ABLE TO CONTROL VEHICLE. THE LEFT SIDE FAILED FIRST NOW THE RIGHT SIDE. EXTREMELY DANGEROUS AND I WAS LUCKY I WAS ABLE TO REACT TO AVOID HITTING CARS NEXT TO ME.*AK

Mar 21, 2007

SERVICE BRAKES, ELECTRIC

2 complaints

ABS LIGHT APPEARED , FOLLOWED BY ANTI SKID LIGHT , NOW WITH WRENCH FLASHING , ON A 2006 FORD EXPLORER , CAUSES IT TO DRIVE TERRIBLE ON GRAVEL , ALL THIS AFTER THE TRANSMISSION AND THROTTLE BODY HAD TO BE REPLACED IN THE LAST SIX MONTHS, MY CAR HAS 80,000 MILES AND DRIVES LIKE ITS 20 YEARS OLD AND ABOUT THAT RELIABLE. LIGHT HAS BEEN ON OVER A WEEK. *TR

Aug 02, 2010

ON TWO OCCASIONS (MAY 2009 AND NOW JUNE 2010) A TONE RING IN MY 2006 FORD EXPLORER'S ABS/TRACTION CONTROL SYSTEM BROKE. IT CAUSED THE TRACTION CONTROL AND BRAKES TO GO HAYWIRE. THEY BEGAN TO GRAB AND LOCK MY BRAKES WHEN I WAS MOVING CAUSING ERRATIC DRIVING. WHEN I WENT TO STOP, MY BRAKES DID NOT WORK PROPERLY. I HAVE READ ON FORD FORUMS THAT THIS IS AN ONGOING ISSUE WITH NUMEROUS FORD EXPLORER OWNERS. *TR

Jun 04, 2010

POWER TRAIN,EQUIPMENT

2 complaints

TL*THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT SINCE THE VEHICLE WAS PURCHASED THE AIR CONDITIONER HAS MALFUNCTIONED. THE GEAR SHIFT ALSO MOVED OUT OF PARK OWN ITS OWN. THE CONTACT TOOK THE VEHICLE TO THE DEALER. THE DEALER CONFIRMED THAT THERE WAS A RECALL ASSOCIATED WITH HER VIN FOR THE GEAR SHIFT AND MADE THE NECESSARY REPAIRS. WHENEVER THE VEHICLE SHIFTS GEARS ON ITS OWN IT WOULD LUNGE FORWARD AND A METAL ODOR WAS WITHIN THE VEHICLE. THE DEALER INFORMED THE CONTACT THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE CONTACT STATED ALSO STATED THAT THE VEHICLE WAS VERY UNSAFE TO DRIVE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 54,730.

Feb 26, 2010

I OWN A 2006 FORD EXPLORER AND WHEN I SLOW DOWN TO STOP , I FEEL AN AWFUL JERK, JUST AS SOMEONE IS REAR-ENDED ME. FOR SOME REASON, WHEN I SLOW DOWN TO A STOP LIGHT OR SIGN, THE TRANSMISSION JERKS THE VEHICLE WHEN SHIFTING FROM 2ND DOWN TO 1ST GEAR. THIS IS DEFINITELY NOT WHAT FORD HAS MADE THE EXPLORER FOR, TO SHIFT WITH A SUDDEN JERK FROM GEAR TO GEAR. THIS IS NOT REALLY A SAFETY ISSUE, BUT CAUSES REAL PROBLEMS WHEN YOU EXPECT THAT YOU'VE PURCHASED A GREAT VEHICLE, BUT YOU ACTUALLY DIDN'T. I KNOW THAT I'M NOT PAYING FOR THIS MISTAKE OR FLAW IN DESIGN OF THE 2006 FORD EXPLORER. I WILL FIGHT THIS ISSUE TO THE END AS A MARTYR, AND I'M NOT KIDDING ABOUT THIS. *TR

Nov 11, 2009

ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM

2 complaints

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. WHEN ATTEMPTING TO MAKE A TURN, OR DECELERATE, THE ENGINE WOULD STALL. THE VEHICLE WAS TAKEN TO THE DEALER OVER FIVE TO SIX TIMES FOR IDENTICAL FAILURES. THE DEALER REPLACED THE FUEL FILTER AND THE POWER TRAIN MODULE . NONE OF THE REPAIRS HAVE REMEDIED THE FAILURE. THE FORD MANUFACTURER WAS CONTACTED, BUT NO ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 25,800. UPDATED 1/25/10 *CN UPDATED01/26/10.*JB

Dec 09, 2009

TL*THE CONTACT OWNS A 2006 FORD EXPLORER. SINCE OCTOBER OF 2008, THE VEHICLE STALLS AT ANY SPEED AND THE ACCELERATOR BECOMES DIFFICULT TO DEPRESS. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE AUTOMATICALLY STALLS WHEN ATTEMPTING TO BRAKE. WHEN ATTEMPTING TO ACCELERATE AFTER THE FAILURE, THE VEHICLE JUST SHUTS OFF. THE VEHICLE HAS BEEN TAKEN TO THE REPAIR SHOP FOUR TIMES REGARDING THE BRAKE FAILURE AND STALLING, BUT THE CAUSE OF THE FAILURE HAS YET TO BE DETERMINED. THE CONTACT STATED THAT THIS IS A SAFETY ISSUE AND SHE WOULD LIKE THE FAILURE INVESTIGATED. THE CURRENT AND FAILURE MILEAGES WERE 74,000. UPDATED 10/21/09 *BF UPDATED 10/21/09*JB

Mar 18, 2009

POWER TRAIN,UNKNOWN OR OTHER,LANE DEPARTURE

1 complaint

Hi, I purchased my 2006 ford explorer in 2019 from a mechanic lot. Since then I’ve changed the muffler, all 4 of the o2 sensors. Recently, after changing parts like the cylinder, spark plugs and wires as well as another set of o2 sensors and the EGR Valve, Mass Air flow sensor and the EGR sylenoid valve I have been getting check engine light with the emissions code not passing inspection. At this point my registration is at hand and the mechanics that change the parts can’t seem to understand why the check engine light did not go off. However an additional code came on in regards to the heater. As per PEP Boys mechanic shop and Auto Zone the emissions keep failing and may need a new computer- however when a part is removed the computer is able to pick that up issuing out another code. Please assist Thank you, [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

May 27, 2025

POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

1 complaint

Complete failure of the powertrain electrical harness. Heat degradation to wire insulation has exposed all conductors. Several other owner operators have experienced the same issue wherein the Dealer has attempted repair of existing trouble codes, by replacing sensors, modules and components. Problems range from vehicle shut-off at speed, vehicle fires, no-start and failed PCM modules due to short to power or short to ground. Based on my findings, this specifically impacts vehicles ranging from 2006-2010, Ford Explorer or Mercury Mountaineer with the 4.0L SOHC engine.

Jun 06, 2022

SEAT BELTS,SEATS

1 complaint

THE UNIT HAS ISSUES WITH THE SEAT BELTS. I CALLED THE DEALER BUT THEY SAID THAT THEY DON'T HAVE ANY RECALL CAMPAIGN REGARDING THIS ISSUE, AND NO GUARANTY CAN BE APPLY.

Dec 18, 2020

WHEELS,SERVICE BRAKES,ENGINE

1 complaint

I HAVE NOW HAD 2 PROBLEMS WITH THIS DEALERSHIP, AND PERSONALLY I BELIEVE EVERYONE DESERVES SECOND CHANCES, THE FIRST VEHICLE THE SELLER SOLD ME HAD MAJOR ISSUES WITH GAS TANK HAD A HOLE IN IT AND EXPOSED WIRES RIGHT NEXT TO IT SO THAT TRUCK WAS A TICKING TIME BOMB, NOW I HAVE A 2006 FORD EXPLORER WITH MORE ISSUES BUT AGAIN THE SELLER MAKES ITS SEEM LIKE A PRETTY RELIABLE CAR AND LIES ABOUT THE ISSUES, COVERS UP THE STORIES AND THANK GOD MY BUDDY IS A MECHANIC AND I TAKE EVERYTHING I BUY TO HIM, WHEN I FIRST RECEIVED THE CAR, (AS MANY PEOPLE NOT MANY PEOPLE KNOW ANYTHING AS SOON AS THEY HEAR A WEIRD NOISE) I TOOK IT TO HIM AND HE RIDES WITH ME AND NOTICES SOME MAJOR ISSUES, I TOOK IT FOR A DRIVE AND THE BACK SUSPENSION WAS GOING OUT (GOT THAT REPLACED) THEN THE TRANSMISSION SLIPPING , LIKE NOT ONLY WAS LIED TO BUT NOW HAVING TO PAY 2000$ JUST TO KEEP THE CAR RUNNING, NOT SUITABLE FOR ME NOR ANYONE, I FEEL BAD FOR WHOEVER THIS SELLER ALSO LIES TO. AND I AM FULLY AWARE THAT SOMEONE COULD GET THEIR LICENSE REVOKED FOR STUFF LIKE THIS, IF ANYONE WITH CLEAR EYES CAN SEE THIS SELLER SCREWS PEOPLE OVER. I TEXTED THE GUY ABOUT RETURNING THE VEHICLE AND JUST TO GET MY MONEY BACK BUT YET AGAIN NO ANSWER.

Nov 22, 2019

POWER TRAIN,VISIBILITY/WIPER

1 complaint

1. REAR WIPER QUIT WORKING SEVERAL YEARS AGO. SLUGGISH AND NOW FROZE UP. HASN'T WORKED FOR A LONG TIME. 2. REPLACED RADIATOR SEVERAL YEARS AGO. REPLACED THERMOSTAT SEVERAL TIMES OVER THE YEARS. THEN... 2018, SEPTEMBER,-- DISAPPEARING COOLANT FROM RADIATOR FOR LAST 6 MONTHS WITH NO OBVIOUS LEAK. CAR OVER HEATED IN AUGUST BUT NO OBVIOUS LEAK. KEPT REFILLING... 3 DAYS AGO BOTTOM THERMOSTAT HOUSING SPRUNG A BIG LEAK AND CAR OVERHEATED MAJOR. REPLACED THERMOSTAT, AND FULL THERMOSTAT HOUSING. INTERNET RECOMMENDS UPDATING SOFTWARE BECAUSE OF OVERHEATING, BUT IS PRICED AT ABOUT $110 AT ALL DEALERSHIPS.

Oct 05, 2018

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,ENGINE

1 complaint

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT VARIOUS WARNING INDICATORS FLASHED AND THE VEHICLE STALLED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FLY BY WIRE PEDAL AND THE THROTTLE BODY WERE REPLACED, BUT THE FAILURE CONTINUED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

Apr 09, 2018

STEERING,POWER TRAIN,ENGINE

1 complaint

TRANSMISSION IS SLIPPING BAD AND CAR NOT SHIFTING INTO DRIVE

Aug 25, 2017

STEERING,ELECTRONIC STABILITY CONTROL (ESC),ENGINE

1 complaint

THE CAR WAS SOLD WITH LIMITED WARRANTY, USED, BUT HAD WRITTEN COLD START ISSUE. THE VEHICLE GETS WARM IF WARM OUTSIDE AND WILL JUST COMPLETELY SHUT OFF ANYWHERE AT ANYTIME. RIDING DOWN INTERSTATE, WILL LOSE POWER THEN SHUT OFF AND LEAVE YOU WITH NO POWER STEERING TO CONTROL VEHICLE GOING HIGH SPEEDS, WILL SHUT OFF IN TOWN MULTIPLE TIMES UPWARD OF A DOZEN OR MORE TIMES WHILE DRIVING, 1ST SHOP SENT TO SAID COULDN'T FIND ISSUE SECOND THEY SENT ME TOO SAID COMPUTER NEEDED REPLACING. EITHER WAY I NEVER WOULD HAVE PURCHASED IT WITHOUT IT BEING DONE HAD U KNOWN, MY FIANCE IS SMALL AND NO WAY SHE COULD HANDLE THE VEHICLE IF SHUTTING DOWN WHILE DRIVING. ITS VERY DANGEROUS AND IS GOING TO GET SOMEONE KILLED IF NOT REPAIRED AND LOOKED INTO MORE CLOSELY.

Jul 06, 2017

UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM

1 complaint

HAVE A SEVERE GAS SMELL IN THE CAB HAVE HAD 3 DIFFERENT AUTO MECHANIC SHOPS LOOK AT IT CANT FIND THE SOURCE HAD GAS LINES REPLACED, GAS FILTER AND SMOKED NOTHING THEY ARE STUMPED AND MY PEOPLE ARE GOOD WANT TO KNOW WHAT THE ######## ARE YOU GONNA DO ABOUT THIS PROBLEM FORD. HELP ITS MAKING ME HAVE HEADACHES N FEEL SICK AND IT SMELLS SITTING AND DRIVING. ITS NON STOP N GETTING WORST.

Mar 16, 2017

POWER TRAIN,SERVICE BRAKES,FUEL/PROPULSION SYSTEM

1 complaint

DRIVING DOWN THE HWY THE POWERTRAIN MALFUNCTION INDICATOR CAME ON. I LOST ALL USE OF THE FUEL PEDAL AND BRAKE. HAD TO GET TO THE SIDE OF THE HWY WITH OUT DYING. IF I TURN THE CAR OFF AND BACK ON THE INDICATOR IS GONE AND WORKS JUST FINE. THIS SITUATION HAS HAPPENED AT LEAST 5 TIMES IN THE LAST 3 MONTHS. NOTHING SHOWS UP WHEN I PLUG IN A CODE READER. *TR

Oct 18, 2016

ELECTRICAL SYSTEM,AIR BAGS

1 complaint

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THE PASSENGER SIDE AIR BAG INDICATOR ILLUMINATED, WHICH INDICATED THAT IT WAS DEACTIVATED EVEN WHEN A PASSENGER WAS IN THE FRONT SEAT. THE VEHICLE WAS TAKEN TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 107,522.

Sep 22, 2016

ELECTRICAL SYSTEM,ENGINE

1 complaint

CAR SHUTS OFF WHILE DRIVING. THIS HAS HAPPENED ABOUT 6 TIMES IN THE LAST TWO MONTHS. ALWAYS AT SPEEDS UNDER 40 MPH AND ALWAYS WITHIN 3 MINUTES OF TURNING THE CAR ON. THERE'S NEVER ANY WARNING OR SMELL OR SOUND. DASH GOES BLACK, RADIO CUTS OFF, POWER STEERING FAILS, AND I HAVE TO COAST TO THE SIDE OF THE ROAD. OBVIOUSLY THIS IS VERY FRIGHTENING AND I'VE BEEN VERY LUCKY THAT IT HAS NOT YET HAPPENED AT LIGHTS OR TURNS. MY CAR GUY IS REALLY GOOD AND HE'S AT A LOSS. HE THINKS MAYBE IT'S A SECURITY SYSTEM MALFUNCTION. I DRIVE WITH CHILDREN IN THE CAR AND I CAN'T AFFORD A TO BUY A NEW CAR. I'M NOT SURE WHAT MY OTHER OPTIONS ARE.

Sep 06, 2016

AIR BAGS,SEATS

1 complaint

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. WHEN THE VEHICLE WAS STARTED, THE PASSENGER SIDE AIR BAG WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT THE FRONT PASSENGER SEAT WAS OCCUPIED; HOWEVER, THE WARNING LIGHT REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER TO BE DIAGNOSED. THE MECHANIC WAS UNABLE TO RETRIEVE A FAULT CODE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 103,000. UPDATED 11/29/16*LJ

Jul 26, 2016

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

WE RECENTLY BOUGHT OUR TRUCK IN MARCH 2016 AND SINCE ABOUT APRIL OF 2016 THE TRUCK CONTINUOUSLY SHUTS OFF, IN TRAFFIC, ON THE HIGHWAY, ON RESIDENTIAL ROADS..PRETTY MUCH ANY AND EVERY WHERE, IT HAPPENS WHILE DRIVING AND WHILE IDLING. ALL POWER IS LOST INCLUDING POWER STEERING. SOMETIMES IT WILL SHUT OFF 2/3 TIMES IN A 5-10 MINUTE SPAN WILL DRIVING. IT HAS CUT OFF ON ME TWICE WHILE DRIVING THROUGH INTERSECTIONS WHILE I HAD MY CHILDREN IN THE CAR WITH ME ALMOST RESULTING IN ACCIDENTS BOTH TIMES. SOMETIMES WHILE DRIVING IT LOSES POWER THEN SUDDENLY REGAINS POWER BACK AND WILL CONTINUE TO DRIVE. THIS IS AN ALL ROUND DANGEROUS AND POTENTIALLY DEADLY SITUATION! AFTER DOING SOME RESEARCH IT SEEMS AS IF THIS IS A VERY COMMON PROBLEM WITH THESE VEHICLES. I'VE CONTACTED FORD MYSELF AND SO FAR THEY HAVEN'T ISSUED A RECALL AND ARE AWARE OF THIS SITUATION. PLEASE HELP!!

Jul 03, 2016

POWER TRAIN,UNKNOWN OR OTHER,ENGINE

1 complaint

CHECK ENGINE LITE AND ORANGE WRENCH LITE WHICH SHUTS CAR DOWN NO EXCELRATION PEDAL POWER STEERING GONE AND NO BRAKE CONTROL ON FREEWAY COMING HOME. TRANS. WILL NOT SHIFT AND JUMPS WHEN WRENCH LITE IS ON VERY DANGEROUS THIS HAS BEEN GOING ON SINCE APRIL TOOK BACK TO DEALER SENT TO MECHANIC REPLACED 2 PARTS ON EXCELLERATION MODULE. STILL NOT RIGHT.

Jun 28, 2016

SUSPENSION,ELECTRICAL SYSTEM,ENGINE

1 complaint

TAKATA RECALL

May 05, 2016

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE

1 complaint

I BOUGHT A 2006 EXPLORER IN 2010 AND IN 5 YEARS I HAVE HAD A SENSOR THAT'S GOES INSIDE THE TRANSMISSION REPLACED, THEN TRANSMISSION REBUILTED, AND THE RADIATOR REPLACED TWICE. NOW THAT IT'S PAID OFF LEAKING COOLANT AGAIN MAKING IT RUN HOT. NOW IT SAYING CHECK THE CHARGING SYSTEM AND STOP ON ME ON THE FREEWAY AND NOW WON'T STAY STARTED. THOUGHT I WAS DOING EVERYTHING RIGHT WITH THE MAINTENANCE OF THE TRUCK BUT IT KEEPS BREAKING DOWN. ALSO THE WRENCH THING IS ON AND WON'T STAY STARTED EVEN WHILE PRESSING THE GAS PEDAL TO THE FLOOR ALL AFTER I JUST HAD ANOTHER SENSOR REPLACED. AND BESIDES THE RADIATOR LEAKING AGAIN THAT PLASTIC THING THEY CALL A THERMOSTAT HOUSING MAY BE CRACKED. I FEEL I'M SPENDING MORE MONEY REPAIRING THINGS ON THIS TRUCK IN 5 YEARS THAT MOST PEOPLE SPEND ON A NEW CAR. IF I HAD SEEN ALL THE PROBLEMS THIS MODEL YEAR WAS HAVING WOULD HAVE WENT A DIFFERENT BRAND.

Jan 27, 2016

POWER TRAIN,SERVICE BRAKES

1 complaint

EDDIE BAUER V8 2006 EXPLORER 107000 MILES THE ABS AND SRV LIGHTS CAME OFF. THE CAR WAS STUCK TO THE GROUND AND WOULD NOT SPEED AT ALL. GOT A MECHANIC TO CHECK AND MANY DIFFERENT CODES SHOWED UP. IN THE PAST WHEN THE SAME LIGHTS CAME UP I TOOK THE CAR TO A FORD DEALER AND THEY FOUND NOTHING.THEY RECOMMENDED TO CHANGE THE FRONT TIRES BUT THEY COULDN'T FIND ANY PROBLEMS. FOR WHAT I KNOW IT SEEMS THE FORD EXPLORER HAS A LOT OF PROBLEMS AND FORD REFUSES TO DO A RECALL TO FIX IT.

Nov 12, 2015

ELECTRICAL SYSTEM,ELECTRONIC STABILITY CONTROL (ESC),ENGINE

1 complaint

DRIVING ON A HIGHWAY I-95 IN FLORIDA. THE VEHICLE STARTED TO MISS AS WE ACCELERATED. WE TOOK THE CAR INTO A FORD DEALER SERVICE FOR PLUG REPLACEMENT. THIS AUTO HAS A 4.6 LITRE V-8 ENGINE. WE WERE AMAZED TO FIND THAT IT WILL COST UPWARDS OF $1000.00 TO REPLACE 8 SPARK PLUGS. THAT COST ESCULATES IF ANY PLUGS ARE BROKEN. THE PLUGS ARE TWO PIECE CONSTRUCTION AND SEPARATE ON REMOVAL. ONLY FORD CAN REMOVE THE PLUGS AND MORE WILL BE CHARGED FOR ANY BROKEN. IT IS IMPOSSIBLE TO REMOVE THESE PLUGS WITHOUT BREAKAGE. FORD RECOMMENDS NOT CHANGING THE PLUGS UNTIL 100,000 MILES. BY THAT TIME YOU ARE OUT OF GUARANTY AND IF THEY ARE HARD TO COME OUT AT 60,000 MILES IMAGINE IF THEY ARE LEFT IN. THESE PLUGS ARE KNOWN TO BLOW OUT OF THE HEAD AND I AM SURE THERE ARE MANY ACCIDENTS. I AM A DISABLED VETERAN 83 YEARS OLD AND A MECHANICAL ENGINEER. MY WIFE AND I ARE FISHERMEN AND NEED A VEHICLE TO BRING OUR BOAT TO WATER. WE ARE AVID FORD OWNERS AND ARE GREATLY DISSAPOINTED.

Sep 26, 2015

ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

1 complaint

MY CAR SLOWED DOWN TO A CRAW IN THE HIGHWAY AND HAD TO LIMP HOME AT VERY LOW SPEED ALMOST CAUSED A CRASH.

Jul 13, 2015

PARKING BRAKE

1 complaint

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. WHILE ATTEMPTING TO RELEASE THE EMERGENCY BRAKE, IT FRACTURED. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE EMERGENCY BRAKE ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 66,000.

Feb 27, 2015

STEERING,SERVICE BRAKES,ENGINE

1 complaint

WE BOUGHT THIS USED FROM A USED CAR DEALERSHIP. THE VERY NEXT DAY I NOTICED WHILE DRIVING THE ENGINE JUST SHUT OFF. COUPLE MONTHS LATER THE SAME THING HAPPENED AND HAS CONTINUED TO HAPPEN OFTEN. LAST WEEK I WAS DRIVING 45 MPH ON A HIGHWAY IN THE RAIN AND LOST ALL CONTROL OF THE VEHICLE. THE BRAKES DIDN'T WORK, THE STEERING DIDN'T WORK, THE ENTIRE CAR SHUT DOWN, I HAD A PANIC ATTACK BECAUSE I WAS IN TRAFFIC AND ALMOST CAUSED A HUGE ACCIDENT WITH OTHER VEHICLES. I PUT ON THE HAZARDS AND FINALLY WAS ABLE TO DRIFT INTO A THE MIDDLE OF THE ROAD CALLED THE TURNING LANE. I CALLED THE DEALERSHIP MANY TIMES AND HAVE ONLY BEEN TOLD "WE ARE SORRY". I TRIED CALLING A LEMON LAW LAWYER BUT WAS TOLD, SORRY, IF THE TRUCK WAS A 2007 THEN I WOULD HAVE A CASE. SO, NOW WHAT DO I DO? I HAVE A 10,000 CAR LOAN FOR A VEHICLE THAT I AM FRIGHTENED TO DRIVE ANYWHERE. PLEASE HELP ME. *TR

Jul 04, 2014

STEERING,AIR BAGS

1 complaint

I WAS IN THE PROCESS OF PARKING MY 2006 FORD EXPLORER XLT, PULLING VERY SLOWLY INTO MY PARKING SPOT, WHEN THE ENGINE STARTED ROARING, IT LUNGED, HIT A PARKING CURB AND THEN THRUST INTO A CONCRETE PILLAR IN A PARKING GARAGE. THE AIRBAG DEPLOYED AND ENGINE DIED. MY VEHICLE WAS TOTALED! I RECEIVED BURNS FROM THE AIR BAG CHEMICALS ON BOTH OF MY HANDS. I'M STILL SHAKEN UP ABOUT IT. NECK IS SORE AND LOWER BACK HURTS. *TR

Jun 04, 2014

Crash: 1

Injuries: 1

ENGINE AND ENGINE COOLING,ENGINE

1 complaint

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 40 MPH, THERE WAS A LOUD NOISE IN THE FRONT END AS THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT HAD ALREADY TAKEN THE VEHICLE TO AN AUTHORIZED DEALER WHO REPLACED THE RADIATOR TWICE BUT THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHO DIAGNOSED THAT THE RADIATOR AND ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE MULTIPLE TIMES AND PROVIDED NO REMEDY. THE APPROXIMATE FAILURE MILEAGE WAS 44,000. THE VIN WAS NOT AVAILABLE.

May 15, 2014

POWER TRAIN,ELECTRONIC STABILITY CONTROL (ESC),ENGINE

1 complaint

DRIVING AT 45 MPH ,TRANSMISSION SHIFTED WITH A JERKY MOTION ,FIRST STARTED THEN.WHEN YOU FIRST TAKE OFF IT JERKS AND MAKES A NOISE. WHEN YOU BACK UP IT JERKS HARD ENOUGH IT WHIPS YOU BODY BACK. HAD IT CHECKED AT A TRANSMISSION PLACE. THEY TORE IT DOWN AND FOUND NOTHING ( $400). STILL JERKS AND SHIFTS ROUGH. DON'T KNOW HOW LONG IT'S GOING TO LAST. *TR

Feb 27, 2014

FUEL SYSTEM, GASOLINE,POWER TRAIN,ENGINE

1 complaint

DEAR SIR FIRST OF ALL , I WOULD LIKE TO STATE THAT I AM NOT A US CITIZEN , BUT , I'M A FAMILY MAN & I FEEL FOR OTHERS , I OWN A FORD EXPLORER 06 , AND RECENTLY I'VE BEEN NOTICING THAT THE TRANS HAS A MIND OF IT'S OWN , SHIFTING WRONGLY , JOLTING INTO GEAR IS NOT ENJOYABLE OR SAFE, THE OTHER DAY I WAS ABOUT TO HAVE AN ACCIDENT BECAUSE THE TRANS REFUSED TO SHIFT WHEN I TRIED TO ACCELERATE IN ORDER TO ESCAPE A SITUATION OF HITTING A CAR NEXT TO ME , I'VE LOOKED IT UP ON THE INTERNET & FOUND THAT EVERYBODY IS COMPLAINING OF THE SAME ISSUES , YOU CAN GO FOR THE BELOW SITE & CHECK HTTP://WWW.CARCOMPLAINTS.COM/FORD/EXPLORER/2006/TRANSMISSION/TRANSMISSION_LUNGES_HARD_JOLT_WHEN_SHIFTING.SHTML THE PROBLEM IS THAT FORD WON'T ADMIT THAT THERE IS SOMETHING WRONG WITH THE TRANSMISSION , PUTTING PEOPLES LIFE IN DANGER FOR A FEW DOLLARS MORE PLEASE FIX THIS AS IT'S VERY CRITICAL & DANGEROUS AT THE SAME TIME [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Jan 01, 2014

ENGINE AND ENGINE COOLING,POWER TRAIN,VISIBILITY

1 complaint

I HAVE HAD THE DOOR BLENDER PLASTIC PIECE CHANGED ON MY CAR THREE TIMES! EACH TIME THE SEASON CHANGES. I NOW HAVE TO REPLACE IT AGAIN. I CURRENTLY HAVE A RADIATOR LEAK AND WILL HAVE TO REPLACE THE RADIATOR AND PLASTIC HOLDER AS WELL. I ALSO CURRENTLY HAVE A TRANSMISSION SLIPPAGE PROBLEM AND I WILL HAVE TO GET THAT FIXED AS WELL. THIS IS HORRIBLE. I PURCHASED THE FORD EXPLORER BECAUSE I THOUGHT IT WAS DEPENDABLE. THIS IS DEPRESSING AND I CAN NOT AFFORD IT! *TR

Oct 22, 2013

POWER TRAIN,VEHICLE SPEED CONTROL,SERVICE BRAKES

1 complaint

WHILE ATTEMPTING TO SHIFT EXPLORER FROM PARK TO REVERSE THE TRANSMISSION DID NOT ENGAGE FOR 5 TO 10 SECONDS WHEN IT FINALLY DID ENGAGE THERE WAS A LOUD NOISE THAT SOUNDED AS IF THE TRANSMISSION FELL OUT OF THE VEHICLE AND THE VEHICLE LUNGED WITH GREAT FORCE. THE HAS OCCURRED ON MANY OCCASIONS AND IS POSSES A DANGER TO MYSELF AND FAMILY AND ANY ONE WHO MAY BE PARKED OR STANDING TO CLOSE. I HAVE HAD THIS VEHICLE IN TO MY LOCAL FORD SERVICE CENTER AND THEY HAVE BEEN UNABLE TO RESOLVE THE PROBLEM. THE VEHICLE WAS TAKEN IN TWICE WHILE UNDER WARRANTY: FIRST TIME THEY STATED THEY COULD NOT FIND ANYTHING AND THE SECOND TIME THEY REPLACED THE SHIFTING MECHANISM. IN NOVEMBER OF 2012 THE ENGINE WOULD NOT ENGAGE AT ALL AND HAD TO BE TOWED TO MY LOCAL FORD DEALER AND THEY STATED THAT IS WAS THE GEAR SHIFTER AGAIN, THIS TIME I PAID $500 TO HAVE IT REPAIRED. THE CAR WORKED CORRECTLY FOR ABOUT 3 MONTHS AND I THOUGH IT WAS FINALLY FIXED, HOWEVER IT IS ONCE AGAIN DOING THE SAME THING. IT DELAYS 5-10 SECONDS BETWEEN SHIFTING, DROPS INTO GEAR VERY HARD AND LUNGES FORWARD. FORD IS NOW TELLING ME I NEED A NEW TRANSMISSION AT THE FANTASTIC PRICE OF AN ESTIMATED $2500. GIVEN ALL THE COMPLAINTS ABOUT THIS TRANSMISSION I THINK FORD NEEDS TO REPLACE THEM AT THEIR COST BEFORE WE START SEEING AN INCREASE IN TRANSMISSION FAILURE CRASHES, INJURIES, AND POSSIBLY FATALITIES. *TR

Aug 20, 2013

SERVICE BRAKES,ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

UPON STARTING THE VEHICLE IT SUDDENLY EXCELERATES. I NOW KEEP MY FOOT ON THE BRAKE AT ALL TIMES IMMEDIATELY FOLLOWING IGNITION. IT HAS HAS HAPPENED FOUR OR FIVE TIMES IN THE LAST SEVERAL MONTHS. I HAVE OWNED THE VEHICLE SINCE 2007 WHEN I PURCHASED IT FROM OCALA LINCOLN MERCURY AS A FORD CERTIFIED VEHICLE. IT HAD APPROXIMATELY 14,000. TODAY IT HAS ONLY 54,230 MOSTLY HIGHWAY. THAT IS LESS THAN 7000 MILES PER YEAR. ITR HAS REGULAR SERVICES AT MY LOCAL FOR DEALER. ALL OF MY REPAIR RECORDS ARE OBTAINABLE THROUGH THE FORD MOTOR COMPANY.

Jun 09, 2013

SERVICE BRAKES, HYDRAULIC,POWER TRAIN,TIRES,ENGINE

1 complaint

WITH ONLY 86,000 MILES OUR FORD EXPLORERS TRANSMISSION HAS FAILED ONCE AGAIN. WHEN WE HAD 23,000 MILES ON OUR VEHICLE WE NOTICED THE TRANSMISSION WAS SHIFTING RATHER HARD AND TOOK IT TO THE DEALER AND THEY FOUND NOTHING WRONG. AT 58,000 MILES THE TRANSMISSION ENGAGEMENT WAS SO ROUGH THAT WE HAD TO GET IT REPAIRED. SINCE THE WARRANTY IS ONLY UP TO 36,000 WE DECIDED OUR BEST BET IS TO NOT TAKE IT TO THE DEALER. WE HAD THE VALVE BODY REPAIRED AND IT RAN FINE UP UNTIL NOW. 86,000 MILES AND THIS VEHICLE IS ONCE AGAIN AT A REPAIR SHOP HAVING THE TRANSMISSION FULLY REBUILT. IN THE TIME I HAVE OWNED THIS VEHICLE I HAVE PAID OVER $7,000 TO KEEP IT RUNNING WITH REGULAR MAINTENANCE, TIRES, RADIATOR REPAIR, BRAKES AND NOW THE THIRD TRANSMISSION. *TR

Apr 01, 2013

ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES

1 complaint

BRAKES SHUTTERED AND MAKE AWFUL RACKET WHEN TRYING TO STOP. ABS AND ESC LIGHT CAME ON. TOOK IT TO FORD HOUSE AND WAS TOLD A REAR "EXCITER RING" HAD BROKEN AND WOULD NEED TO BE REPLACED AT $380. *TR

Feb 02, 2013

POWER TRAIN,UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM

1 complaint

THIS VEHICLE HAS BEEN JERKING WHEN I AM GOING SLOW TO THE POINT AS IF SOMEONE HIT ME IN THE REAR END OF THE VEHICLE. IT IS A VERY STRONG JERKING SENSATION ENOUGH TO FRIGHTEN ANY REASONABLE INDIVIDUAL. IT ALSO HAS BEEN TRYING TO ACCELERATE WHEN MY FOOT WAS ON THE BRAKE PEDAL AND NOT IN CRUISE CONTROL WHILE GOING WELL BELOW THE MINIMUM SPEED NECESSARY TO USE THE CRUISE CONTROL. THE AUTO ACCELERATION WAS WHILE AT 10 MILES PER HOUR OR LESS AND MY FOOT WAS ON THE BRAKE. THIS HAS BECOME MORE AND MORE FREQUENT AND I AM WORRIED IT COULD BE THE COMPUTER, THE TRANSMISSION, THE ENGINE, OR A CONTROL SYSTEM NOT FUNCTIONING PROPERLY. THIS HAS HAPPENED ON MULTIPLE OCCASIONS WITH PASSENGERS IN THE VEHICLE. MY PARENTS WERE FRIGHTENED WHEN IT HAPPENED. I AM WORRIED THE THING MAY ACCELERATE ON ITS OWN AND HURT ANOTHER VEHICLE(S) OR ITS PASSENGERS. THERE HASN'T BE A FIRE OR CRASH YET BUT IT IS MY FEAR THAT WILL HAPPEN UNLESS THIS SAFETY ISSUE IS MEANINGFULLY ADDRESSED. I ALREADY HAD CERTIFIED AUTO REPAIR OF ROCKVILLE MD LOOK AT THE VEHICLE AND THEY TOLD ME THEY COULDN'T FIND ANYTHING WRONG FOLLOWING A COMPUTER DIAGNOSTIC. THE JERKING AND AUTO ACCELERATION ARE BECOMING MORE AND MORE FREQUENT AND I AM REPORTING THIS BECAUSE I AM CONCERNED ABOUT THE SAFETY OF MY VEHICLE AND OTHERS ON THE ROAD. ALSO, THERE ARE HEAVY VIRBATIONS OCCURING DURING THE IDLING PROCESS AND I AM NOT A MECHANIC BUT THIS MAY HAVE SOMETHING TO DO WITH THE SAFETY CONCERNS ON THE VEHICLE. *TR

Jan 14, 2013

VEHICLE SPEED CONTROL,SERVICE BRAKES

1 complaint

MOST OF THE TIME, MY 2006 FORD EXPLORER V8 WILL JERK FORWARD VERY HARD WHEN STOPPING. THIS USUALLY HAPPENS WHEN I APPROACH STOPS SIGNS OR STOP LIGHTS. IT FEELS LIKE I'VE BEEN REAR-ENDED BECAUSE OF HOW HARD THE JOLT IS. THIS COULD CAUSE ME TO STRIKE ANOTHER VEHICLE OR CRASH INTO A WALL IF PARKING INSIDE A STRUCTURE. THE VEHICLE ALSO SOMETIMES JERKS VERY HARD FORWARD WHEN ACCELERATING FROM A STOP. *TR AFTER RESEARCHING ONLINE, THIS ISSUE APPEARS TO BE A MAJOR PROBLEM THAT FORD KNOWS ABOUT, AND APPARENTLY HAS DONE NOTHING TO FIX IT. *TR

Oct 31, 2012

ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

I NOTICED A YELLOW FLUID LEAKING FROM THE THERMOSTAT HOUSING. I TOOK IT TO A MECHANIC AND HE SAID THAT THE ANTIFREEZE WAS LEAKING FROM SOMEWHERE IN THE MANIFOLD, PROBABLY THE THERMOSTAT HOUSING. WE REPLACED THE THERMOSTAT HOUSING AND BRAND NEW O-RINGS AND ADDED SILICONE SEALANT AROUND THE AFFECTED AREAS. WE ARE STILL SEEING THE LEAKING. I HAVE SEEN THIS COMPLAINT NUMEROUS TIMES AND IT IS TIME THAT FORD TAKE RESPONSIBILITY FOR THE PLASTIC PARTS THAT ARE CONNECTED TO THE ENGINE. FORD MUST USE METAL PARTS TO REPLACE THESE FOR ME BECAUSE PLASTIC WARPS IN THE HEAT OF FLORIDA. THE AFFECTED PARTS ARE THE THERMOSTAT HOUSING AND IT'S CONNECTION TO THE ENGINE. I HAVE A 2006 FORD EXPLORER EDDIE BAUER 4.0 WITH 55K MILEAGE. GOOD MAINTENANCE ALWAYS, OIL CHANGED REGULARLY, FLUIDS CHECKED AND MAINTAINED REGULARLY. FORD MUST FIX THIS! *JS

Jun 07, 2012

SERVICE BRAKES, HYDRAULIC,ELECTRONIC STABILITY CONTROL (ESC),TRACTION CONTROL SYSTEM

1 complaint

WHILE DRIVING ON THE FREEWAY AND APPLYING MY FOOT ON THE BRAKES THE VEHICLE FAILED TO STOP. ABS, TRACTION CONTROL AND A WRENCH LIGHT CAME ON. GRINDING NOISE CAME FROM THE VEHICLE. THIS INCIDENT HAPPENED WHILE DRIVING MY WIFE AND NEWBORN HOME FROM THE HOSPITAL. AFTER TAKING IT TO A SHOP, THE MECHANIC NOTICED THAT THE TONE RING OR ABS RING WAS CRACKED. THIS MUST BE REPLACED IN ORDER FOR THE VEHICLE TO HAVE FUNCTIONAL BRAKES. THE SHOP TOLD ME THAT THE ABS RING HAD A DIFFERENT PART NUMBER AND THE MATERIAL WAS MUCH THICKER THAN THE OLD RING. *TR

Mar 13, 2012

ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE

1 complaint

HAVING PROBLEMS WITH FLUID OVERFLOWING TO THE OVERFLOW TANK, OVERHEATING AND CYLINDER MISFIRE READINGS. *TR

Feb 20, 2012

POWER TRAIN,ELECTRICAL SYSTEM,AIR BAGS

1 complaint

THE AIR BAG MALFUNCTION LIGHT AND WRENCH LIGHT BOTH LITE UP ON THE DASH. THE CAR APPEARED TO BE RUNNING STRANGE, SHIFTING HARD. AFTER TURNING OFF THE VEHICLE, IT WOULD NOT RESTART FOR APPROX 20 MINUTES. IT WOULD RUN FINE FOR A DAY OR SO THEN THE LIGHTS WOULD COME ON AGAIN. TOOK THE CAR TO THE FORD DEALERSHIP, THEY DROVE IT FOR APPROX 23 MILES AND THE LIGHTS WOULDN'T COME ON. THE BATTERY TESTED LOW SO THEY REPLACED THE BATTERY. WHEN TEST DRIVING AFTER THE BATTERY REPLACEMENT THE WRENCH LIGHT AND AIRBAG LIGHT FINALLY CAME ON. THEY TURNED OFF THE VEHICLE AND IT WOULDN'T START. AFTER WAITING 15 MINUTES TO AN HOUR IT WOULD START BUT THE LIGHTS WOULD COME ON AGAIN AND ONCE AGAIN AFTER TURNING IT OFF IT WOULDN'T RESTART. THEY CHARGED ME AN ADDITIONAL $759 TO FIX THE INSTRUMENT CLUSTER (AFTER AROUND $300 FOR THE BATTERY AND DIAGNOSTIC TESTING). VERY FRUSTRATING - MY 2006 ONLY HAS 47K MILES AND IS RARELY DRIVEN. *TR

Jan 04, 2012

ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE,UNKNOWN OR OTHER

1 complaint

WHILE DRIVING THE VEHICLE, THE SMELL OF ANTIFREEZE STARTED COMING INTO THE CAR. MY FIANCE' CHECKED THE RADIATOR AND OVERFLOW BOTTLE AND FOUND OUT IT WAS GAS MIXED WITH THE ANTIFREEZE. MY CAR'S MILEAGE IS 80100. I DO NOT BELIEVE THE CAR SHOULD HAVE THIS ISSUE AT ONLY 5 YEARS. THIS PROBLEM/COMPLAINT SHOULD BE INVESTIGATED AND DAMAGES SHOULD BE COVERED BY THE DEALERSHIP OR MANUFACTURER. *TR

Nov 04, 2011

STEERING,SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING

1 complaint

ENGINE STALLS. WHENEVER IT FEELS LIKE IT, HOT OR COLD, SLOWING DOWN TO STOP, TURNING LEFT OR RIGHT, ON THE STREET ROADS AND FREEWAYS. STARTS AND GO AGAIN AFTER 5/10 MINUTES BUT THIS IS RIDICULOUS. I PAID SO MUCH MONEY AND TIME FOR DIAGNOSTIC AND PARTS ALREADY AND YESTERDAY WAS THE WORST. MY 2006 FORD EXPLORER STALLED IN THE MIDDLE OF THE FREEWAY. DATE: NOV 1, 2011, TIME:1550, AND MY WIFE WAS DRIVING, WHEN SHE'S NOT HAPPY, NOBODY'S HAPPY....SHE ALMOST GOT RAN OVER AS SHE OPEN HER DOOR, SHE COULD NOT GO ANYWHERE BUT WAIT FOR TIME TO EITHER COOL OFF OR RESET ON THE ENGINE. *TR

Nov 02, 2011

SERVICE BRAKES, HYDRAULIC,POWER TRAIN

1 complaint

AT RANDOM TIMES AND NOT OFTEN, WHEN I PUT THE SUV IN PARK, AND TURN OFF THE TRUCK AND REMOVE MY FOOT FROM THE BRAKE, THE TRUCK WILL CONTINUE TO ROLL. IT IS AS THOUGH THE SUV IS IN NEUTRAL, PUT IT IS IN PARK. THE SUV WILL ROLL UNTIL SOMETHING STOPS IT LIKE A CURB OR APPLYING THE BRAKE. TO FIX THE PROBLEM, I HAVE TO PLACE THE SHIFT GEAR TO FROM PARK TO ANOTHER GEAR AND BACK TO PARK. AT THAT TIME, THE TRUCK WILL CATCH. OVER THE PAST YEAR OR SO, IT HAS OCCURRED 6 OR 7 TIMES. I TOOK THE TRUCK IN FOR SERVICE AND THEY CHECKED THE TRANSMISSION AND GEAR BOX AND FOUND NO ISSUE. THE PROBLEM OCCURRED AGAIN LAST WEEK. SINCE THE DEALER CANNOT SEE THE PROBLEM, THEY SAY THERE IS NO PROBLEM. HOWEVER, IT IS A MATTER OF TIME OF WHEN IT OCCURS AND I AM NOT AWARE OF IT NOT LOCKING AND IT ROLLS WHEN THERE IS NOBODY TO STOP IT OR A CURB. THERE IS NO PATTERN SINCE IT HAS OCCURRED AT WORK, GROCERY STORE, HOME, ETC. *TR

Oct 08, 2011

SERVICE BRAKES, HYDRAULIC,POWER TRAIN,ELECTRICAL SYSTEM,ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

THE WRENCH, THE ABS, AND THE ANTI-SWAY ICONS STARTED COMING ON INTERMITTENTLY ON MY 2006 EXPLORER. THEY WOULD RESET IMMEDIATELY USING THE RESET BUTTON. THE DEALER REPLACED A WHEEL-SPEED SENSOR AND STATED THAT THE SENSOR WAS DAMAGED WHEN THE "TONE" WHEEL CRACKED. DEALER ALSO STATED THAT UNLESS THE TONE WHEEL WAS REPLACED, THE ABS WAS NOT OPERATIONAL. SEEMS LIKE THIS IS A MAJOR SAFETY CONCERN; IF YOU THINK YOU HAVE ABS, BUT DON'T THE DRIVER IS SET UP FOR THE BIG FALL! FORD IS AWARE OF THIS CRACKING PROBLEM: WHY NO RECALL? *TR

Jul 25, 2011

SERVICE BRAKES, HYDRAULIC,ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

ABS BRAKE LIGHT AND INTERMITTENT LOCKING UP BRAKES WITH STABILITY CONTROL ALMOST CAUSING ACCIDENT AS YOU LOSE CONTROL WHILE DRIVING. *TR

Jun 07, 2011

ENGINE AND ENGINE COOLING,VISIBILITY

1 complaint

TL* THE CONTACT OWNS A 2006 FORD EXPLORER EDDIE BAUER. WHILE DRIVING APPROXIMATELY 10-60 MPH, THE VEHICLE BEGAN TO JERK ABNORMALLY. THE VEHICLE WOULD ALSO OVERHEAT SPORADICALLY AND THE REAR WINDSHIELD WIPERS WOULD NOT OPERATE. THE VEHICLE WAS TAKEN TO A LOCAL TRANSMISSION SPECIALIST WHERE THEY REBUILT THE TRANSMISSION AND ATTEMPTED TO REPAIR THE REAR WINDSHIELD WIPERS BUT TO NO AVAIL. THE FAILURE PERSISTED AND THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR THE FAILURES. THE DEALER MADE REPAIRS TO THE COOLING SYSTEM BUT WAS UNABLE TO DISABLE THE REAR WINDSHIELD WIPERS TO MAKE REPAIRS. THE FAILURE MILEAGE WAS 100,000. UPDATED 04/25/11 *BF UPDATED 1/13/2012 *LN *TR

Mar 10, 2011

POWER TRAIN,SEATS

1 complaint

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE WAS IN PARK AND WHEN ATTEMPTING TO SHIFT INTO REVERSE, THE VEHICLE EXHIBITED AN UNUSUAL DROPPING NOISE AND BEGAN TO JERK VIOLENTLY. IN ADDITION, WHEN STARTING THE ENGINE THE VEHICLE WOULD OFTEN LUNGE FORWARD ABNORMALLY. WHEN BRAKING, THE VEHICLE WOULD ALSO JERK VIOLENTLY AS IF SOMEONE HAD CRASHED INTO THE REAR OF THE VEHICLE. THE CONTACT ALSO STATED THAT SHE WAS UNABLE TO SEE OUT OF THE PASSENGER REARVIEW MIRROR WHEN THE SECOND ROW SEAT WAS UPRIGHT BECAUSE THE HEADREST WAS OBSTRUCTING HER VIEW. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER SEVERAL TIMES WHO WAS UNABLE TO DUPLICATE THE FAILURE. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS APPROXIMATELY 109,000 AND THE FAILURE MILEAGE WAS APPROXIMATELY 38,000.

Mar 08, 2011

CHILD SEAT

1 complaint

SUNSHINE KIDS RADIAN 80SL CONVERTIBLE CAR SEAT. WHEN INSTALLED REAR-FACING WITH LATCH, THE ADJUSTER MECHANISM ENDS UP ON THE EDGE OF THE BELT PATH, PREVENTING THE BELT FROM STAYING TIGHT, EVEN WITHOUT ANY INTERFERENCE. IT CAN CAUSE A PERSON TO THINK THAT THE SEAT IS TIGHTLY INSTALLED WHEN IT IS NOT. THE ONLY SOLUTION IS TO INSTALL WITH THE SEAT BELT. (RELATED VEHICLE INFORMATION: MODEL YEAR=2006, MAKE=FORD, MODEL=EXPLORER). *TR

Aug 24, 2010

FUEL SYSTEM, OTHER,POWER TRAIN,VEHICLE SPEED CONTROL

1 complaint

JUST RECENTLY NOTICED MY 06 FORD EXPLORER HAVING UNEXPECTED ENGINE SURGES. WENT TO STOP AT AN INTERSECTION AND IT FELT LIKE THE VEHICLE WAS FIGHTING ME TO STOP. WHEN THE LIGHT TURNED GREEN I GAVE IT A LITTLE GAS HOWEVER THE VEHICLE BEGIN TO MAINTAIN THAT SPEED LIKE I HAD THE CRUISE CONTROL ON. I PURPOSELY DID NOT GIVE THE VEHICLE ANY GAS AND SAW THAT IT JUST KEPT ACCELERATING. FINALLY AFTER BREAKING OUT I BEGAN TO BRAKE AND AGAIN FELT THE VEHICLE ACCELERATING. SINCE NO ONE WAS IN FRONT OF ME I WANTED TO SEE WHAT THE VEHICLE DID IF I GAVE IT A LITTLE GAS IN WHICH IT MADE A POPPING SOUND AND DID NOT RESPOND WHEN I GAVE IT MORE GAS BUT THE ENGINE STILL WAS RUNNING. I PULLED OVER AND PUT THE VEHICLE IN PARK. I TRIED TO REV THE ENGINE BUT IT DID NOT RESPOND. A WRENCH LIGHT CAME ON DURING THIS PROCESS. I TURNED THE VEHICLE OFF THEN ON AGAIN IN WHICH IT SEEMED THERE WAS NOTHING WRONG. AS I DROVE HOME IT DID FINE EXCEPT WHEN STOPPED AT THE SAME INTERSECTION IT DIED. I STARTED IT AGAIN AND HAD NO PROBLEMS AND I DID MAKE IT HOME. AFTER SOME RESEARCH I FOUND MULTIPLE SIMILAR PROBLEMS LIKE THIS WITH THIS VEHICLE HOWEVER NO RECALLS HAVE BEEN ISSUED. I HAVE AN 8 YEAR OLD SON AND DO NOT FEEL COMFORTABLE DRIVING THIS VEHICLE. AT THIS TIME WE CANNOT AFFORD TO GET THIS FIXED. WHAT ARE MY OPTIONS AT THIS POINT OTHER THAN MAKING A COMPLAINT? PLEASE HELP! I'M A HARD WORKING AMERICAN THAT LIKES TO BUY VEHICLES MADE IN THE USA HOWEVER WE AS A NATION NEED TO HELP OUT WITH THESE ISSUES SO WE ALL CAN CONTINUE TO SUPPORT AMERICAN CAR PURCHASES. THANKS *DT

Mar 22, 2010

ELECTRICAL SYSTEM,INTERIOR LIGHTING

1 complaint

THE GEAR SHIFT LIGHT ON MY 2006 FORD EXPLORER HAS BURNED OUT. THE SERVICE DEPARTMENT OF MY DEALER SAID I HAVE TO BUY AN ENTIRE SHIFT UNIT AND WAS TOO EMBARRASSED TO EVEN CHECK THE PRICE. I BELIEVE THIS IS A POTENTIAL HAZARD SINCE PEOPLE WON'T REPLACE THE ENTIRE UNIT DUE TO COST AND WILL PLACE THE CAR IN THE WRONG GEAR AT NIGHT LEADING TO INJURY. DON'T KNOW HOW MANY OTHERS HAVE THIS PROBLEM, BUT FOUND A FEW ON LINE. *TR

Dec 04, 2009

ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

DAUGHTER DRIVING MOTHER'S 2006 FORD EXPLORER ON NYS RT 87, ABS LIGHT, TRACTION CONTROL LIGHT AND WRENCH LIGHT COME ON, NEAREST EXIT A FEW MILES. ABS WOULD OPERATE RANDOMLY, FORTUNATELY NO ACCIDENT. GRINGING SOUNDS FROM TRANSFER CASE. I FOUND THE DRIVER'S SIDE REAR TOOTHED RING KNOWN AS THE "EXCITER RING" WAS CRACKED AND LOOSE ON THE AXLE WHICH CAUSES THE SENSOR TO GET BAD READINGS. I AM GOING TO FORD DEALER FOR REPAIR, BUT A VEHICLE WITH 55K SHOULD NOT HAVE THIS PROBLEM. I HOPE IT HASN'T CAUSED ANY OTHER PROBLEMS. THIS COULD EASILY CAUSE A CRASH BECAUSE YOU WOULD NOT EXPECT ABS TO FUNCTION WHEN YOUR FOOT IS NOT ON THE BRAKE PEDAL. *TR

Apr 27, 2009

SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING

1 complaint

TRAC CONTROL, ABS, CHECK ENGINES LIGHTS ON. RATTLE ON LEFT REAR AXLE, ABS RING LOOSE FORM AXLE, NEED TO REPLACE RING AND AXLE. *TR

Apr 21, 2009

STRUCTURE,INTERIOR LIGHTING

1 complaint

SINCE 11/08, WE NOTICED THE OVERHEAD CONSOLE LIGHT WOULD LEAK WATER AFTER VARIOUS RAINFALLS. ON 12/1/08 WE TOOK THE SUV TO THE DEALER FOR SERVICE OF THIS MATTER. IT WAS RELEASED TO US ON 12/3/08. THE CORRECTION WAS: INSTALLED UPDATED DRAIN TUBES, AS PER 07-20-6. ON 3/2/09 WE BROUGHT THE SUV TO THE DEALER FOR SERVICE, FOR THE SAME - OVERHEAD CONSOLE, DOME LAMP LEAKING, & FULL OF WATER, AND ROOF (HEADLINER) ABOVE REAR SEAT ON DRIVER'S SIDE LEAKING AND SOAKED WITH WATER AFTER VARIOUS RAINFALLS. THE CORRECTION THIS SECOND TIME WAS: CLEARED DRAINS. ON 3/30/09 WE BROUGHT THE SUV IN FOR SERVICE AGAIN. IT HAD RAINED THROUGH THE NIGHT, AND THE MORNING OF 3/29/09. THE DOME CONSOLE LIGHTS WERE LEAKING & HAD WATER INSIDE, THE ROOF HEADLINER ON THE REAR DRIVER SIDE WAS SOAKED & LEAKING WATER WELL INTO THE TRUNK AREA, AND THE RIGHT SIDE REAR BEHIND THE PASSENGER SIDE WAS SOAKED & LEAKING WATER WELL INTO THE TRUNK AREA AS WELL. WE RECEIVED A PHONECALL FROM THE TECHNICIAN ON 3/31/09, STATING THAT NO LEAKS HAD BEEN FOUND, NO WATER STAINS VISIBLE. WE WENT IN TO SPEAK WITH THE SERVICE MANAGER THAT EVENING, AND SHOWED THE PICTURES TAKEN BY US ON 3/29/09 - SHOWING EXTENSIVE WATER LEAKAGE. THEY KEPT THE SUV TO FURTHER INVESTIGATE FOR LEAKS. ON 4/2/09 WE RECEIVED A CALL FROM THE TECHNICIAN, STATING THE DRAINS WOULD BE REPLACED AGAIN. THE CONSEQUENCES OF THESE EVENTS IS THAT I AM AFRAID TO ALLOW THE CHILDREN TO TURN ON THE DVD PLAYER, SUNROOF, & EVEN FEAR OF DRIVING THE VEHICLE FOR POSSIBLE FIRE HAZARD/ELECTRICAL SAFETY ISSUES. MY HUSBAND HAS LOST DAYS @ WORK WHILE THE TRUCK IS IN SERVICE. MY ASTHMATIC CHILD HAS NOT FELT WELL FOR MONTHS NOW, WHICH LEADS US TO SUSPECT IF DUE TO THE LEAKAGE, THUS WETNESS, IF MOLD IS PRESENT SOMEWHERE IN THE VEHICLE. ALSO, THE DRIVER HEATED SEAT HAS NOT WORKED SINCE 12/09, WHICH LEADS US TO SUSPECT IF THE WATER DAMAGE HAS STARTED CAUSING ELECTRICAL PROBLEMS. *TR

Apr 02, 2009

SUSPENSION,VEHICLE SPEED CONTROL,ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

WHILE DRIVING THE ABS / CHECK ENGINE / RSC WARNING LIGHTS CAME ON. THE TRUCK WAS ABLE TO BE DRIVEN FOR A COUPLE OF MILES, BUT THEN IT STARTED MAKING A NOISE FROM THE REAR OF THE VEHICLE. THE TRUCK WAS NOT ABLE TO BE DRIVEN TO A SAFE LOCATION AND WAS LEFT ON THE SIDE OF A ROAD IN A HIGH TRAFFIC AREA AND WAS TOWED TO THE DEALER. THE DEALER FOUND OUT THE REAR RIGHT TOOTHED RING KNOWN AS AN "EXCITER RING" WAS LOOSE ON THE AXLE. THEY REPORTED THE WHOLE AXLE PART NEEDS TO BE REPLACED BECAUSE OF HOW IT'S MADE AT A COST OF $630 INSTALLED. THEY INDICATED THEY HAD NO REQUIREMENT TO REPORT THIS PROBLEM AND I BELIEVE THIS IS A MAJOR DEFECT WITH UNFORESEEN SAFETY PROBLEMS THAT IS BEING UNDER REPORTED. MY TRUCK ONLY HAD 50K MILES AND I HAVE RESEARCHED MANY OTHER INDIVIDUALS REPORTING THE PROBLEM ON CAR AND TRUCK FORUMS. I HAVE INDICATED ON THE FORUMS TO REPORT THIS DEFECT TO YOUR WEB SITE AND INCLUDED THE LINKS. THE FORUMS ARE INDICATING FORD KNOWS OF THE PROBLEM AND MY DEALERSHIP SAID THEY HAVE THE SAME PROBLEM HAPPEN ONCE IN A WHILE. WE HAVE A LONG TRIP SCHEDULED SOON AND I CAN'T IMAGINE WHAT WOULD HAPPEN TO THE VEHICLE WHILE DRIVING AT HIGHWAY SPEEDS WITH ANOTHER TOOTHED SENSOR RING FALLING OFF. I DO NOT FEEL SAFE LETTING MY WIFE AND KIDS DRIVE IN THIS VEHICLE KNOWING THAT THERE ARE THREE OTHER AXLES WITH POTENTIALLY THE SAME PROBLEM. THE COMPANY THAT MADE THIS PART SHOULD BE INVESTIGATED FOR A DEFECTIVE PART THAT COULD CAUSE DIRECT OR INDIRECT DEATH AND/OR INJURIES. *TR

Mar 20, 2009

SERVICE BRAKES, HYDRAULIC,VEHICLE SPEED CONTROL

1 complaint

2006 FORD EXPLORER BRAKES MALFUNCTIONED. CONSUMER STATES THAT SHE APPLIED THE BRAKES BUT THE VEHICLE ACCELERATED OUT OF CONTROL. *NJ THE CONSUMER STATED THE VEHICLE PLUNGED INTO THE WATER. THE VEHICLE WAS DEEMED TOTALED. *JB

Sep 26, 2008

POWER TRAIN,VISIBILITY,EQUIPMENT

1 complaint

WHEN THE CAR STOPS, STARTS OR DRIVES SLOW... IT JERKS WHEN CHANGING GEARS FROM 1ST THROUGH 3RD, BOTH UP- AND DOWN SHIFTING. IT HAS ALSO STARTED TO SLOW (FOR NO APPARENT REASON) WHEN DRIVING AT A STEADY SPEED ON THE HIGHWAY (GOING AROUND 65-70 MILES AN HOUR), I HAVE HAD MULLINAX FORD LOOK AT THE TRANSMISSION 5 TIMES NOW, AND IT IS STILL THERE. CURRENTLY I AM INVOLVED IN A LEMON LAW CASE TRYING TO GET FORD TO BUY MY CAR BACK. THEY ARE STATING THAT THERE IS NO SIGNIFICANT PROBLEM WITH MY TRANSMISSION AND AT THE SAME TIME SAYING THAT IT IS DUE TO ABUSE OR NEGLECT ON MY PART ???? I CAN ONLY SUGGEST THAT OTHERS TAKE THE SAME ROUTE - THE MORE THE BETTER TO GET THE ATTENTION OF FORD TO COMPLETELY FIX THIS PROBLEM. I ALSO HAVE HAD MY COMPASS WORKED ON (DID NOT SHOW ANYTHING OR JUST TWO LINES) , THE GEAR SHIFTER REPLACED (WOULDN'T SHIFT OUT OF 'P'), THE REAR WINDOW REPLACED (DUE TO WATER LEAK) AND THE AIR CONDITIONING SYSTEM REPLACED AS THERE WAS SOMETHING BEND ???. I ALSO HAVE EXPERIENCED THAT WHEN WORK HAS BEEN DONE ON THE CAR THE BREAKS WORKED DIFFERENTLY AFTERWARDS. IN MY OPINION THE 2006 FORD EXPLORER IS A LEMON. *TR

Apr 30, 2008

EXTERIOR LIGHTING

1 complaint

THIS APPLIES TO ALL OF THE NEWER CARS, TRUCKS ETC. I DON'T KNOW WHAT THE NEW HEADLIGHTS ARE CALLED, BUT THEY ARE BRIGHT WHITE OR BLUISH IN TINT. I HAVE EXPERIENCED MANY TIMES WHERE THE ONCOMING CARS WITH THESE LIGHT BLIND ME TO THE POINT I CAN'T SEE THE ROAD IN FRONT OF ME. I DON'T KNOW WHAT CAN BE DONE SINCE MORE AND MORE PEOPLE HAVE THESE LIGHTS AND US THEM IN CONJUNCTION WITH FOG LIGHTS. PLEASE LOOK INTO THIS MATTER, I CAN'T BE THE ONLY PERSON WITH THE SAME ISSUE. THANK YOU STANLEY PRZYBYLSKI *TR

Feb 06, 2008

ENGINE AND ENGINE COOLING,POWER TRAIN,STRUCTURE,EQUIPMENT

1 complaint

HAVE HAD NUMEROUS PROBLEMS STARTING WITH A LIFTER STUCK IN MOTOR AT 296 MILES, TO TRANSMISSION FAILURE AT 15,700 MILES. BRAKES HAVE SQUEAKED SINCE IT WAS NEW, OVERHEAD CONSOLE HAS FALLEN OFF TWICE, SATELLITE RADIO WORKS WHEN IT WANTS TO. DOOR RUBBED ON RUNNING BOARD, NOW GAS MILEAGE HAS DROPPED UNDER 10 MILES PER GALLON. 14 TRIPS TO DEALERSHIP SO FAR AND STILL NOT ALL IS FIXED. *TR

Dec 31, 2007

POWER TRAIN,EQUIPMENT,ELECTRICAL SYSTEM

1 complaint

2006 FORD EXPLORER WITH FREQUENT TRANSMISSION PROBLEMS. CUSTOMER STATES THAT THE TRANSMISSION HAS SHIFTING INCONSISTENCIES WHICH CAUSES THE VEHICLE TO SHAKE. *KB THE CONSUMER STATED THE ERRATIC SHIFTING OF THE VEHICLE STARTED THE DAY AFTER PURCHASE AND AFTER THE INCIDENT HE CONTACTED THE DEALERSHIP TO INFORM THEM OF THE DEFECT. THE DEALERSHIP THEN IN TURN HAD THE CONSUMER COME IN ON 4 SEPARATE OCCASIONS TO RECTIFY THE SITUATION BUT TO NO AVAIL. THE CONSUMER WOULD LIKE THE SITUATION INVESTIGATED AND WOULD LIKE FOR THE DEALER TO REPURCHASE THE VEHICLE AT THE VALUE IN WHICH IT WAS SOLD. THE DEALER STATED THE SPEAKERS SOUND LIKE THEY ARE DISTORTED, TOP COVER OF INSTRUMENT CLUSTER IS LOOSE. *TR

Aug 28, 2007

SUSPENSION,SERVICE BRAKES, HYDRAULIC

1 complaint

TL*THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT BOTH THE ANTILOCK BRAKE AND ANTI-ROLL LIGHTS ILLUMINATED. HE HEARD A NOISE COMING FROM THE REAR OF THE VEHICLE AND DISCOVERED THAT THE PASSENGER SIDE REAR AXLE FAILED. THE CONTACT SPOKE WITH THE DEALER AND THEY STATED THAT NO RECALLS WERE AVAILABLE FOR THAT COMPONENT. THE SPEED WAS UNKNOWN. THE CURRENT MILEAGE WAS 41,000 AND FAILURE MILEAGE WAS 40,000.

Aug 20, 2007

VEHICLE SPEED CONTROL,ELECTRICAL SYSTEM

1 complaint

TL*- THE CONTACT STATED THAT THE 2006 EDDIE BAUER FORD EXPLORER'S DASHBOARD INSTRUMENT LIGHTS TURNED ON AT ANY GIVEN TIME OF THE DAY. THE CONTACT STATED THAT IF THE LIGHTS TURNED ON WHILE DRIVING THE SPEEDOMETER FAILED TO REGISTER THE CORRECT SPEED. WHEN THE FAILURE HAPPENED SHE PULLED THE VEHICLE TO THE SIDE OF THE ROAD AND SHUT THE IGNITION OFF, BUT IT TOOK SEVERAL ATTEMPTS TO RESTART THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO THE DEALERSHIP ON 8 OCCASIONS, AND THE DEALERSHIP HAS REPLACED THE INSTRUMENT CLUSTER, THE ANTI THEFT MODULE, AND THE COMPUTER. ALSO UNPLUGGED AND PLUGGED ALL THE WIRES UNDER THE HOOD. THE CONTACT STATED THAT SHE CONTINUED TO HAVE THE SAME PROBLEM WITH THE VEHICLE. THE FAILURE MILEAGE WAS 1000 AND THE CURRENT MILEAGE WAS 8485.*AK

Mar 23, 2007

SERVICE BRAKES, HYDRAULIC,POWER TRAIN,VEHICLE SPEED CONTROL

1 complaint

I OWN A 2006 EXPLORER EDDIE BAUER WITH 3000 MILES ON IT. HERE IS THE PROBLEM, JUST BEFORE COMING TO A COMPLETE STOP AT STOP LIGHT, STOP SIGN OR WHATEVER, THE ENGINE REVS TO 1200-1500 RPMS FOR JUST A BRIEF SECOND. I AM NOT GIVING THE CAR ANY GAS TO INDUCE THIS OCCURRENCE. I HAVE NO IDEA WHY THE CAR IS DOING THIS AND NEITHER DOES MY LOCAL DEALER. THE SERVICE MANAGER ACKNOWLEDGED THAT THE CAR IS IN FACT DOING WHAT I DESCRIBED ABOVE, BUT COULD NOT OFFER A FIX. I TESTED ANOTHER 2006 V6 EXPLORER WITH 3 MILES ON IT, TO MINE AND THE SERVICE MANAGER SURPRISE; IT DID THE EXACT SAME THING AS MY TRUCK. THE SERVICE MANAGER SAID HE WOULD LOOK INTO THE SITUATION AND CALL SOME OF HIS ENGINEER BUDDIES TO SEE IF THEY COULD GIVE HIM ANY INFORMATION. I NEVER HEARD BACK FROM HIM. I AM ALSO BEGINNING TO NOTICE THAT I ACTUALLY HAVE TO BREAK HARDER TO GET THE TRUCK TO COME TO A COMPLETE STOP. THIS CAN NOT BE NORMAL, YET MY FORD DEALER IS INSINUATING NOTHING IS ACTUALLY WRONG WITH THE CAR. LONGER THAN NECESSARY STOPPING DISTANCES AND WILL LEAD TO UNNECESSARY COLLISIONS. BECAUSE THE FORD MOTOR COMPANY WILL NOT ADMIT THERE IS A PROBLEM WITH 2006 V6 EXPLORERS MY DEALER WILL PROBABLY DO NOTHING TO REMEDY THE SITUATION. I COMPLAINED TO FORD MOTOR COMPANY AND NEVER EVEN RECEIVED A CONFIRMATION THAT THEY RECEIVED MY EMAIL. I HONESTLY BELIEVE THAT THIS IS A RECALL SITUATION. TO MY KNOWLEDGE, ALL 2006 V6 EXPLORERS EXHIBIT THIS PROBLEM OF SUDDEN ACCELERATION, ADMITTEDLY NOT BY ANY STRETCH A POWERFUL SUDDEN ACCELERATION BUT STILL IT IS A SUDDEN ACCELERATION. I AM CONFIDENT IN MY ASSESSMENT BECAUSE I HAVE PERSONALLY DRIVEN 2 EXPLORERS AND DIFFERENT SERVICE REP CLAIMED HE DROVE YET ANOTHER 06 EXPLORER THAT DID EXACTLY THE SAME THING. IT SEEMS TO ME THAT IF FORD HAS A DESIGN FLAW IN ONE OF THERE CARS THEY SHOULD DESIGN A FIX FOR THE PROBLEM AND THEN REPAIR THE AFFECTED CARS. *NM

Sep 16, 2006

TIRES,SEATS

1 complaint

2006 FORD EXPLORER LIMITED DRIVER SEAT WOULD NOT RETAIN MEMORY ON #2 SETTING. WHEN EXITING THE VEHICLE THE SEAT WONT GLIDE BACK UNTIL THE #2 BUTTON IS PUSHED. TIRE PRESSURE LIGHT ILLUMINATED. *KB THE DEALER HAD TO REPROGRAM THE SEAT MEMORY MODULE AND REPROGRAM BOTH REMOTES. THE DEALER RESET THE TIRE PRESSURE SENSORS. *NM

Sep 16, 2006

PARKING BRAKE,POWER TRAIN

1 complaint

UPON RELEASING THE EMERGENCY BRAKE THE CAR ROLLED DOWN THE HILL AND OVER MY LEGS. *JB

Feb 14, 2006

Crash: 1

Injuries: 2

ELECTRICAL SYSTEM,EQUIPMENT

1 complaint

ON 12/10/05, I PURCHASED A NEW 2006 FORD EXPLORER. YESTERDAY, FOR THE FIFTH TIME, THE VEHICLE HAS NOT BEEN ABLE TO START. I BROUGHT IT IN TO FORD ON 01/11/06, THEY REPLACED THE BATTERY AND TOLD ME IT WOULD NOT HAPPEN AGAIN. IT HAPPENED AGAIN LAST NIGHT. *JB

Feb 06, 2006

2006 FORD Explorer Problems & Complaints

Complaints by Component

Frequently Asked Questions

How many problems does the 2006 FORD Explorer have?

What are the most common problems with 2006 FORD Explorer?

Where does this 2006 FORD Explorer problem data come from?

Other Years - FORD Explorer

Other FORD Models

Similar Brands