How many problems does the 2011 FORD Explorer have?

The 2011 FORD Explorer currently has 1169 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2011 FORD Explorer?

The most common problems reported for the 2011 FORD Explorer are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2011 FORD Explorer problem data come from?

All problem and complaint data for the 2011 FORD Explorer comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.

2011 FORD Explorer Problems

STEERING

600 complaints

My vehicle is subject to NHTSA Safety Recall 14S06 related to loss of electric power steering assist. The Power Steering Control Module was reprogrammed in 2014, and Ford now considers the recall closed based on that reprogramming. In 2025, the vehicle again experienced loss of electric power steering assist and currently exhibits the EPAS diagnostic trouble code associated with the recall defect. This condition has been verified by a Ford dealer. On November 13, 2025, the dealer attempted reprogramming of the steering control module as a diagnostic and customer service step to determine whether reprogramming would resolve the condition. This attempt did not correct the defect, and the loss of steering assist persists. Supplement 3 to Recall 14S06, issued in 2019, includes a Dealer Q&A section (Attachment 4, Question 3) that specifically addresses what happens if a customer experiences loss of steering assist after the module has been reprogrammed. Ford’s guidance states that any subsequent loss of assist after reprogramming may be eligible for extended coverage under a related program. This guidance acknowledges that reprogramming alone may not prevent recurrence of the defect and that further corrective action may be required when the loss of assist returns. Despite this acknowledgment, Ford has denied further remedy solely because the recall is marked “closed” in its internal system and because the vehicle exceeds the time and mileage limits of customer satisfaction program 15N01. The recall defect remains present in the vehicle, and the original remedy has not been adequate to correct it. I am requesting NHTSA review whether Ford has met its obligation under 49 U.S.C. §30120 to provide an adequate remedy for this safety defect. Component: Steering Issue: Loss of power steering assist Recall Remedy: Remedy failed / not provided

Dec 14, 2025

The contact owns a 2011 Ford Explorer. The contact stated that while driving approximately 35 MPH, there was a grinding sound coming from the steering column while making left and right turns. Additionally, the contact stated that the steering wheel jerked while driving and making left or right turns. The contact stated that three unknown warning lights were illuminated, and the traction control warning light was also illuminated. Additionally, there are unknown messages displayed. The vehicle was taken to a dealer, but the diagnosis was unknown. The manufacturer was notified of the failure. The failure mileage was approximately 193,000.

Dec 12, 2025

I was driving to Independence missouri and the power steering went out, it was difficult to steer and if I was going slow enough I could not turn the wheel at all. There was an alert that popped up stating power steering fault. My mechanic reset the code and it was fixed for about 30 minutes before coming back on. I took it to a Ford dealership in chillicothe missouri and they had to reset the entire module and reprogram it. This fixed the issue for about 2 weeks and it is now doing the same thing as before. I paid $150 for an hour of labor plus diagnostic. I am expecting to take it back to the dealership on 12/3 for the same issue.

Dec 02, 2025

While driving power steering stopped working. Thankfully I was able to pull my vehicle over without incident. My vehicle has not been inspected as of yet by the dealership as I am on SSD called the dealership and the cost is $139.00 to run the diagnostic. Warning lights kicked on as soon as it happened. This was originally supposed to be remedied in recall 15N01 EPAS. I called the dealership and the cost for repair on this issue is extremely expensive compared to what I still owe on my explorer. Updated to show images of what was scanned, which falls under the recall from 2015. I still owe $2800.00n on this vehicle and repairs will cost more than what is owed. I've called Ford and they pretty much do not care

Nov 11, 2025

Steering wheel locked up when I tried to restart car

Nov 01, 2025

+ 595 more complaints for this component

STRUCTURE

88 complaints

Loose/Detached Bilateral Exterior C-Pillar around the rear window. Both sides are lifted and very loose with the potential to cause driver to lose control if detached resulting in damage to other vehicles on the road or even a traffic collision… this is a safety defect

Dec 12, 2025

The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure). The contact became aware that the passenger’s and driver's side A-pillar trims had started to crack, and the pieces were loose. The contact used tape to secure the A-pillar trims. The contact called a local dealer and was informed that the remedy was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not informed of the failure. The failure mileage was approximately 52,000.

Dec 02, 2025

The contact owns a 2011 Ford Expedition. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, parts for the recall repair were not yet available. The contact stated that for two years, the dealer was repeatedly contacted; however, the contact was informed that the parts were not yet available. The manufacturer was contacted; however, the contact was informed that the parts were not available. The contact had not experienced a failure.

Nov 14, 2025

The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Oct 17, 2025

The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving 70 MPH, the passenger’s side A-pillar trim flew off the vehicle. A local dealer was notified of the failure; however, the contact was informed that parts for the recall repair were unavailable. The manufacturer was made aware of the issue. The failure mileage was approximately 125,000.

Sep 22, 2025

+ 83 more complaints for this component

UNKNOWN OR OTHER

69 complaints

My recall 24S02 has not been fixed, Exterior A-Pillar applique. I have been sent 2 letters dated Feb 2024 & July 2024 about this recall, today is 10-17-2025. My dealership is LaFontaine BIrch Run Mi is very good, Ford customer service on the other hand is very very poor. I have been chasing down this recall for over 18 months. When I finally got a hold of someone at Ford's customer service, they [XXX] ) transferred me to my dealership to resolve. The dealership can't make this part. Ridiculous. No one or no incident so far has happened. How long does a car manufacturer have to manufacture parts to complete the recall?? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Oct 17, 2025

Safety Recall 24S02/NHTSA Recall 24V031, this recall hasn’t been fixed until now. The part has been on back order since 2024. It just seems like there’s no solution, it’s always been back order, and I was always advised to call and check back. This has been an ongoing issue, since the recall came out.

Aug 14, 2025

When the vehicle is put in reverse, the backup camera blacks out and if it comes back on, the picture is reversed horizontally. This is causing a hazard when backing up as the camera shows what's actually on the left side to be on the right and vice versa. There are many recalls for the same complaint of Ford's back up system, yet nothing has been addressed for the 2011 model. Thank you!

Aug 02, 2025

ENGINE CARRIER OR CRADLE RUSTED AND CRACKED CAUSING DRIVERS SIDE A ARM TO MAKE WHEEL UNSTEERABLE PULLNG VEHICLE TO THE LEFT. COULD HAVE CAUSED SERIOUS ACCIDENT OR HEAD ON COLLISION AS IT WAS PULLED INTO ONCOMING TRAFFIC LANE. I WAS ABLE TO STEER VEHICLE INTO A PARKING LOT AND HAD TO HAVE IT TOWED TO MY MECHANIC WHO CONFIRMED THE THE CAUSE WAS BY RUST THROUGH ON SUB FRAME ENGINE CARRIER . COMPONENT WAS NOT INSPECTED BY MFGR ,POLICE OR INSURANCE REP. THERE WERE NO WARNINGS OR ANY SYMPTOMS PRIOR TO THE FAILURE. I WAS MAKING A RIGHT TURN AT APPROX 10MPH WHEN I HEARD A SNAP OR CRACK AND LOST CONTROL OF THE STEERING.

Jul 28, 2025

" exterior A pillar applique trim clip attachments are not properly engaged." I recieved a safety recall letter July 2024. I called Zeigler Ford dealership for the repair. They scheduled an appointment and inspected it and said they cannot fix it due to unavailable parts from Ford. This has been going on for a year and supposedly they can't get the parts. Pieces of the rubber around my windshield was flapping around and eventually fell off. When I called Ford customer service, they said first I need to get the vehicle inspected to that I told them I already had it inspected. Then they transferred me to the dealership to schedule an inspection which I don't need because it was already done. They just transferred me and did not answer my question as to why it hasn't been fixed yet, and why they are not supplying parts to the dealership. They basically left it to the service technician to tell me again that there are no parts. They want to give people the run around and let them possibly get injured in unsafe vehicles.

Jul 08, 2025

+ 64 more complaints for this component

ENGINE

39 complaints

Burnt exhaust smell in cabin after hard acceleration. The smell is overwhelmingly bad causing nose and eye burning and coughing. To remedy the smell the windows have to be rolled down to air out the cabin.

Dec 24, 2024

My son was on the highway and his Ford Explorer 2011 just stopped, he could have been killed! He was able to get off safely and had car towed. Our mechanic told us today it is the Water Pump leakage and we need to take to Ford. We called Ford and they said at least $5,000 to repair possibly more. This is a huge safety concern when the act can just stop dead on highway. There are no safety recalls on this water pump. My son was lucky to make it off the highway alive.

May 30, 2024

The internal water pump failed in my 2011 Ford Explorer without any warning signs and the coolant then leaked into my engine causing catastrophic engine failure. We were driving on a busy highway and the Ford Explorer simply started shutting down in the left lane. Nothing would happen when I pushed the gas petal and suddenly all the lights started flashing and heat went to above high. I was barely able to get over to the shoulder as smoke started to come out of the front of the engine. We were extremely afraid of getting hit since the car stalled on the highway only feet from the exit ramp. The car was towed and diagnosed at the Ford Dealership: Internal water pump failed causing engine failure - water mixed with oil. The car received state inspection and oil changed 17 days prior. Paid for engine replacement at the Ford Dealership with costs over $11,000.

Mar 18, 2024

There are exhaust gases entering the vehicle cabin. This is primarily at startup, while sitting at idle in traffic and under acceleration. After visual inspection it appears to be coming from a cracked passenger side exhaust manifold. This is an obvious safety issue and I believe it should have been included in TSB 14-0130 but was told my VIN was not included.

Aug 01, 2023

Was driving down the highway and my car lost power and put me in a very dangerous situation. Looking into the issue, i found out the waterpump was damaged in which is inside the engine and extremely expensive repairs (3000) dollars or more but the engine has been compromised with alot of coolant into the oil. My car is down and im still paying on it so im in very tough situation and believe the manufacturer should fix this situation.

Mar 19, 2023

+ 34 more complaints for this component

STEERING,ELECTRICAL SYSTEM

31 complaints

Loss of power steering

Nov 12, 2025

Power windows and power mirror buttons stopped working and then “Service power steering now” message came on and the steering wheel is locked and very hard to turn. The electrical wiring for the windows run through the power steering gear. The vehicle has not been inspected or repaired

Dec 26, 2024

While driving in the rain, I lost power steering and had several unrelated waring lights come on. Dash lights flickered. Engine continued to run normally but warning lights came on and off. I was able to drive to a safe location and turn the car off. When I restarted the car everything was normal including the power steering. This happened 2 more times on the 12 mile trip home. In the last 60 days this has happened 3 more times during a rain. On one of these occasions the steering came back on like normal with out me stopping.

Jul 20, 2024

While driving the vehicle on a busy street, proceeded to steer car to turn at an intersection and the steering started failing and was extremely hard to steer. The message appeared electronically, saying service power steering now and car then shut down. We immediately got car to independent mechanic. Was not aware of any vehicle recall, but seems to be repaired. Happened very recently. Early Nov. 2023.

Nov 19, 2023

When I turned my Ford Explorer on yesterday, the Power Steering Fault light came one. This has happened in the past, but when I shut off and restart my car, it has always reset and worked. But yesterday, it didn't reset. Besides the power steering, the Advance Trac light is also on. My blinkers will not stay engaged unless I hold the lever. I can't get in to the Ford Dealer for a month. It is very difficult to drive without the power steering working. The warning lamps came on when I started the car. Thankfully this didn't go out when I was driving.

Aug 29, 2023

+ 26 more complaints for this component

POWER TRAIN

25 complaints

The power steering system fault failed .Yes, the power steering system is available for inspection upon request.The failure of the power steering system put my safety and the safety of others at risk because it became extremely difficult to steer the vehicle, especially at low speeds, which could have led to a loss of control and potential accidents.Yes, the problem has been reproduced and confirmed by SUBURBAN FORD OF TROY .The vehicle has been inspected by SUBURBAN FORD OF TROY.There were no warning lamps or messages prior to the failure. The issue first appeared suddenly while driving on September 14, 2024.

Sep 23, 2024

The contact owns a 2011 Ford Explorer. The contact stated that on five different occasions while driving at various speeds, the power steering warning light illuminated, and the steering wheel became firm, making it difficult to steer the vehicle. The contact stated that on one occasion, the vehicle was towed to a dealer where the contact was informed that the power steering gear needed to be replaced. The vehicle was repaired; however, the failure recurred a week later. The manufacture was notified of the failure. The failure mileage was approximately 120,000.

Aug 18, 2023

Driving along and the power steering assist went out. I called dealer and they said if it was over 10 years they didnt have to repair it. According to your website, It has a 15 year window. Please advise

Sep 14, 2022

Between 7/17/20 and 9/7/20 car stalled five times and stopped moving while in drive mode with no warning. Dealer kept car from 7/30/20 to 8/7/20, but problem was not fixed. Car returned to dealer 9/8/20 and kept by them until 9/16/20 when it was returned with problem apparently fixed. No problem since. Diagnosed Throttle Body Failure. Have verifying work order and invoice.

Sep 28, 2021

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, THE CONTACT ENTERED AND STARTED THE VEHICLE. THE VEHICLE WAS SHIFTED INTO REVERSE HOWEVER, WHILE TURNING THE STEERING WHEEL THE VEHICLE FAILED TO OPERATE AS DESIGNED. THE POWER STEERING WARNING LIGHT BECAME ILLUMINATED. THE VEHICLE WAS TOWED TO THE RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED. THE CONTACT SPOKE WITH A REPRESENTATIVE AT TONY SERRA FORD (40905 HIGHWAY 280, SYLACAUGA, AL 35150 (256) 245-5000) AND WAS INFORMED THAT THE VEHICLE WAS NOT UNDER RECALL. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 161,000.

Oct 26, 2020

+ 20 more complaints for this component

AIR BAGS

24 complaints

Pursuant to the attached pdf file this relates to component parts of the air bag system. When these connections fail or have an issue it disables all of the safety features in the vehicle related to the air bag system and will prevent airbag deployment or any operation in a crash. This has been an issue since we purchased the car used with around 35,000 miles on it. Multiple repair attempts have failed. At 61,000 mile I was told that they would have to replace the connections but since it was more than 60,000 miles the cost of that repair would be out of my pocket as they would no longer honor any warranty coverage. Ford customer service in Dearborn agreed with that assessment. The cost estimate at that time was given at a minimum of $3000.00 dollars. This issue remains unresolved to this day and time as I have tried to appeal that decision and while I have tried to find an independent repair shop that would do this work. To date no independent shop will do this as it effects a safety system. At a 100,000+ miles now I am transporting my grandchildren in this car without the benefit of an operating airbag system due to Ford's continued failures.

Oct 22, 2024

2011 FORD EXPLORER. CONSUMER STATED THAT DURING A COLLISION THE AIRBAGS DID NOT DEPLOY.

Oct 25, 2022

Crash: 1

Airbag fault

Apr 07, 2022

AIRBAG SYSTEM MALFUNCTION LIGHT COMES ON AND OFF SEEMINGLY RANDOMLY. NO CORRELATION TO TEMPERATURE OR HUMIDITY. NO CORRELATION TO BEING IN MOTION OR STOPPED. SOMETIMES IT STAYS ON FOR LONG PERIODS OF TIME (I.E. MONTHS). BASED ON RESEARCH I'VE DONE, IT SEEMS THAT WHEN THE AIRBAG INDICATOR IS LIT, THE ENTIRE AIRBAG SYSTEM IS OFF. THIS IS A MAJOR SAFETY ISSUE. AFTER ABOUT 1 MONTH OF IT BEING ON STEADILY, I HAD IT FIXED AT THE DEALERSHIP, FRANKLIN FORD, IN FRANKLIN, MA. THEY FIXED IT THROUGH A TSB WHERE CONNECTORS WERE CLEANED AND RE-GREASED WITH DIELECTRIC GREASE. THIS FIX LASTED ABOUT 1 YEAR. AFTER THIS TIME PERIOD THE AIRBAG LIGHT CAME BACK ON, AGAIN INTERMITTENTLY AND RANDOMLY. AGAIN, AFTER ABOUT 1 MONTH OF STEADILY ON, I TOOK IT BACK TO THE SAME DEALERSHIP, WHERE IT WAS DIAGNOSED TO BE THE SAME ISSUE. THE VEHICLE WAS REPAIRED USING THE SAME TSB METHOD. THIS LEADS TO A LOGICAL ASSUMPTION THAT THIS FIX IS ONLY TEMPORARY AND I WILL CONTINUOUSLY NEED TO HAVE IT REPAIRED. I'VE READ ACCOUNTS ONLINE OF SEVERAL OTHER USERS EXPERIENCING THIS SAME ISSUE.

Oct 10, 2019

AIR BAG LIGHT CAME ON RANDOMLY AND WILL NOT SHUT OFF.

Dec 04, 2018

+ 19 more complaints for this component

ELECTRICAL SYSTEM

22 complaints

Going down road about 40 mph when power steering was lost with lots of warning.

Nov 03, 2023

My rear view camera was replaced in August 2019 as it stopped working. It was an expensive costing $1000 to repair. It just stopped working again. Car has 100500 miles and this is excessive for what I consider a safety feature in a car this large. I was just told by Ford the backlog for a new camera nationwide is greater than 240 units and some customers have waited over 6 months. I searched online and found many complains on model years 2011 forward due to a bad design flaw that allows moisture in a wiring harness causing corrosion / failure. In my opinion, Ford needs to step up to root cause and provide options other than a complete replacement that only temporarily solves the issue

May 24, 2023

I keep losing my power steering. i called ford and they told me the recall to fix it was out dated . this could cause an accident . and shouldnt have a time line to have it fixed . It has happened several times the last year

Aug 09, 2022

HAZARD LIGHTS DO NOT WORK AND I AM HAVING TROUBLE GETTING THIS PROMBLEM SOLOVED.I HAVE BEEN WORKING ON THIS AND I HAVED LOOKED AT VIDEO AND I AM STILL HAVING ISSUES WITH IT THEY WORK SOMETIMES AND SOMETIMES THEY DON'T.. PLEASE HELP!!!!!!!

May 18, 2021

REAR BACK UP CAMERA STOPPED WORKING ABOUT 50% OF THE TIME SO I CANNOT SEE DIRECTLY BEHIND THE VEHICLE WHILE BACKING UP

Apr 20, 2021

+ 17 more complaints for this component

FUEL/PROPULSION SYSTEM

20 complaints

The fuel sending unit goes bad due to the split tank and differential and drive train have to be taken apart and dropped in order to change. Costing over $1,000.00. You can not go under half a tank of gas and if you do you just run out of gas immediately causing you to stop on highways side roads etc.Its very dangerous to have a vehicle that will just all of a sudden run out of gas and no one is paying to get them fixed because of the pricepoint charged to repair. This is Fords faulty work 1000%

Jan 29, 2024

9/25/22 My 2011 Ford Explorer xlt would start jerking when pushing on the gas paddle and then would start losing speed or power. Today is the third day this has happened so I looked on YouTube and entered my symptoms of my car and it suggested it could be my (electronic position sensor). And YouTube told me there is an extended warranty on this part. I have 140000 miles this vehicle. This vehicle has not been inspected or confirmed by a dealership as of yet. There was no warning when this problem began and no warning lights on the dashboard. I am very hesitant in driving this vehicle around town , fearing it may stop completely.

Sep 28, 2022

The vehicle has been in for service at Downs Ford Dealership twice in the past two years for the same issue and has yet to be resolved. When the gas tank is filled with gas, there is overwhelming smell of gas that doesn’t get better until the tank is about half full. The first time the car was in for service, I was told that the gas tank needed to be replaced but they were having trouble finding one. They said to take the car home and they would call when they found one but they never called. The vehicle was brought in a 2nd time to fix the issue in July of 2021. At that time we were told a valve needed to be replaced and charged $500 but it has not fixed the issue. I’m frustrated and tired of wasting $ and time without my car when they don’t seem to be able to fix it. Consumer would like to would like to withdraw the complaint.

Mar 15, 2022

No warning when the fuel relay gasket attached to the pump assembly fails and allows fuel vapor to fill the cabin of the car. Owner safety is at risk of possible fire. I know of 2 Ford dealerships that are aware of the safety hazard.

Dec 28, 2021

AS A REPAIR SHOP OWNER, THE VEHICLE OWNER STATED THAT THERE WAS A STRONG FUEL ODOR AFTER FILLING THE FUEL TANK. I NOTICED FUEL STAINS FROM THE TOP OF THE TANK SO I REMOVED THE TANK AND FOUND FUEL LEAKING FROM THE FUEL PUMP MODULE. I FOUND THE STEEL LOCK RING RETAINING THE MODULE TO THE PLASTIC FUEL TANK HAD RUSTED AND THE RESULTING RUST 'BLOOM' HAD CRUSHED THE PLASTIC FLANGE CAUSING THE FUEL LEAK. I HAVE NOTICED THIS ON ANOTHER CAR ( 2007 DODGE GRAND CARAVAN, VIN [XXX]) JUST LAST WEEK WITH THE SAME ISSUE. AFTER SHARING THE PICTURES WITH A DIAGNOSTIC DISCUSSION GROUP, OTHERS HAVE SEEN THIS AROUND THE COUNTRY AND CANADA, ESPECIALLY IN THE "RUST BELT" STATES. THIS ISSUE SEEMS TO APPLY TO ANY FUEL SYSTEM WITH A PLASTIC FUEL PUMP MODULE AND A STEEL LOCK RING IN A RUST PRONE AREA. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Oct 07, 2020

+ 15 more complaints for this component

STEERING,ELECTRONIC STABILITY CONTROL (ESC)

16 complaints

THE POWER STEERING FAILS, AND IT BECOMES VERY HARD AND ALMOST IMPOSSIBLE TO STEER THE VEHICLE.

May 31, 2016

I WAS MAKING A RIGHT HAND TURN GOING DOWN A HILL ONTO A STREET WHEN THE SENSORS WENT OFF AND THE POWER STEERING STOPPED WORKING. THE CAR REGISTERED TWO WARNINGS. I STOPPED THE CAR IN THE MIDDLE OF THE STREET. I WAS MANUALLY ABLE TO GET IT TO A PARKING LOT BUT IT WAS EXTREMELY DIFFICULT. I DROVE VERY SLOWLY. WHEN I GOT TO THE PARKING LOT, I TURNED THE CAR OFF AND RESTARTED IT. THE WARNINGS DISAPPEARED AND THE CAR FUNCTIONED NORMALLY. I PROCEEDED TO CALL THE DEALERSHIP WHERE I GOT THE CAR FROM TO EXPLAIN THE SITUATION. I SUBSEQUENTLY CALLED THE DEALERSHIP THE FOLLOWING DAY TO VOICE MY CONCERNS AND MAKE AN APPOINTMENT. THE BEST THEY COULD DO WAS A WEEK FROM TODAY. THIS IS A CERTIFIED, PRE-OWNED VEHICLE THAT I PURCHASED LESS THAN A YEAR AGO. *TR

Jun 25, 2014

THIS IS THE 4TH TIME MY VEHICLE HAS LOST ITS POWER STEERING. I WAS DRIVING IN TRAFFIC AT ABOUT 45 MPH AND THE POWER STEERING. I HAVE TO FIND A PLACE ON THE SIDE OF THE HIGHWAY TO PULL OVER AND TURN MY CAR OFF AND WAIT A WHILE THEN RESTART IT AND SOMETIMES IT FIXES THE PROBLEM AND SOMETIMES IT DOESN'T. THERE IS ONLY A MATTER OF TIME THAT THIS WILL HAPPEN GOING AT A HIGHER RATE OF SPEED AND CAUSE INJURY OR WORSE! FORD NEEDS TO RECALL THIS ASAP! *TR

May 13, 2014

I WAS ROUNDING A CURVE IN AN INTERSECTION WHEN THE STEERING BECAME IMPOSSIBLE TO STEER . I MANAGED TO GET IT OFF THE ROAD AND I NOTICED THE TRACTION CONTROLS WERE LIT UP ALONG WITH THE STEERING FAILURE WARRING CAME ON. AFTER RESTARTING THE CAR EVERYTHING RETURNED TO NORMAL. *TR

Nov 06, 2013

WHILE DRIVING TO WORK THE FOLLOWING WARNINGS CAME UP. 1. POWER STEERING FAULT 2. SERVICE ADVANCETRAC SYSTEM CAR BECAME VERY DIFFICULT TO STEER, ALMOST RESULTING IN A MAJOR CAR ACCIDENT AS I WAS APPROACHING A VERY TIGHT TURN ON I75. UPON DOING SOME RESEARCH IT APPEARS THIS ISSUE IS WAY TO COMMON, AND EXTREMELY DANGEROUS. *TR

Aug 26, 2013

+ 11 more complaints for this component

STEERING,POWER TRAIN

11 complaints

The contact owns a 2011 Ford Explorer. The contact stated while driving approximately 30 MPH and making a left turn, the power steering and 4WD suddenly failed, causing the steering wheel to become difficult to turn in either direction. The 4WD was independently deactivated. During the failure, the message "Service Power Steering" and "Service Power Track" were displayed. The cause of the failures was not yet determined. The manufacturer and local dealer were notified of the failures, but no assistance was offered. The failure mileage was 110,000.

Jun 20, 2024

WHILE DRIVING DOWN INTERSTATE 75 FROM GAINESVILLE FL TO LOGANVILLE GA MY POWER STEERING PUMP WENT OUT ! THANKFULLY MY CHILDREN WERE NOT IN THE CAR , BUT EVEN AFTER PULLING OVER AND CUTTING THE VEHICLE OFF TO TRY TO RESET IT IT DID NOT WORK!

Nov 29, 2020

WHILE DRIVING AND WHILE JUST STARTING THE VEHICLE, THE POWER STEERING AND TERRAIN MANAGEMENT SYSTEMS DING LOUDLY ON THE LEFT SIDE OF THE DISPLAY WHILE TELLING ME I HAVE AN ERROR. WHILE DRIVING, THE POWER STEERING DID GO OUT BRIEFLY BUT CAME BACK.

Aug 20, 2019

MY 2011 FORD EXPLORER HAD A FAULTY TRANSFER CASE, WHICH SET ME BACK $2000.00. THE ISSUE I WAS EXPERIENCING WAS A GRINDING NOISE IN MY FRONT END WHILE DRIVING. I WOULD EXPERIENCE HESITATION WHEN INCREASING SPEEDS, AS IF THE TRANSMISSION WAS SLIPPING. WHILE GOING IN REVERSE, THE CAR WOULD STALL AND THE GEAR WOULD LOCK. I WOULD HAVE TO PUT THE CAR BACK IN PARK AND TRY TO REVERSE AGAIN, IN ORDER TO MOVE. MAZDA HAS THE SAME ISSUE WITH THEIR TRANSFER CASE, WHICH IS THE SAME TRANSFER CASE ON THE 2011 FORD EXPLORER!!!!!!! THIS CAR HAS MAJOR ISSUE ACROSS THE BOARD. I JUST RECENTLY REPLACED THE POWER STEERING RACK, WHICH WAS EVENTUALLY RECALLED BY FORD AFTER NUMEROUS COMPLAINTS. THE 2011 FORD EXPLORER TRANSFER CASE SHOULD BE RECALLED BY FORD. THE TRANSFER CASE CAN DISMANTLE AND CAUSE A MAJOR ACCIDENT WHILE YOUR ARE DRIVING!!

Feb 06, 2017

TRAVELING AT LOW SPEED COMING TO A STOP, FELT LIKE A LOST IN POWER AND ADVANCE TRAC SYSTEM FAILURE, POWER STEERING FAILURE WARNINGS GO OFF. I TURN THE VEHICLE OFF, I THOUGHT THE VEHICLE SHUT DOWN. I STARTED DRIVING AGAIN AND SAME THING HAPPEN AT LOW SPEED AT NEXT STOP SIGN. I DROVE A LITTLE FURTHER AND TURN CAR OFF. UPON RETURNING ALL SYSTEMS WERE WORKING FINE. ON 6/19/15 SAME THING HAPPEN AT LOW SPEED, ADVANCE TRAC AND POWER STEERING FAILURE AND STILL NOT WORKING AFTER SEVERAL HOURS SITTING.

Jun 19, 2015

+ 6 more complaints for this component

ENGINE AND ENGINE COOLING

10 complaints

The contact owns a 2011 Ford Explorer. The contact stated that while his daughter was driving at various speeds, the engine overheated. The contact stated that the water pump was leaking, and the contact replaced the water pump himself. No warning lights were illuminated. The contact stated that the vehicle was scanned with an ODB scanner an engine overheating code was retrieved. The contact stated that the radiator cooling fan failed to turn on. The contact stated he had installed a new temperature sensor, but the vehicle was not repaired. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The failure mileage was approximately 200,000.

Jun 14, 2024

The contact owns a 2011 Ford Explorer. The contact stated while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to coast to the shoulder of the roadway, where the vehicle was able to be restarted. There was no warning light illuminated. The vehicle was towed to an independent mechanic, who diagnosed a failure with the water pump and determined that water had leaked into the engine and mixed with the engine oil, resulting in engine damage. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 113,000.

Jan 24, 2024

The contact owns a 2011 Ford Explorer. The contact stated that while a friend was driving approximately 45 MPH, the driver inhaled an excessive amount of carbon monoxide. The friend accidentally drove into a ditch. The vehicle was pulled out of the ditch by nearby residents. The driver was not injured. There were minor damages to the passenger’s side front of the vehicle. The vehicle was taken to the local dealer who diagnosed a failure with plugs underneath the engine. The plugs were not replaced. The manufacturer was notified of the failure. The approximate failure mileage was 168,000.

May 27, 2022

The contact owns a 2011 Ford Explorer. The contact stated that while driving at 45 MPH, the engine temperature hot warning light illuminated as the vehicle began to stall. The contact pulled off to the side of the road as a white smoke started coming from the vehicle. The contact waited for the vehicle to cool down before opening the hood and discovering that the coolant reservoir was empty. The contact added coolant in the reservoir; however, the vehicle failed to restart. The contact then called a family member who was able to jumpstart the vehicle; however, after several miles of driving, the failure recurred. The contact coasted the vehicle into a Walmart parking lot where she purchased more coolant; however, the coolant immediately leaked out of the vehicle. The vehicle was then towed to an independent mechanic and it was determined that the water pump had malfunctioned which led to the engine failure. The manufacturer was notified of failure but offered no assistance. The manufacturer referred her to the NHTSA to file a complaint. The vehicle was then towed to another independent mechanic where it remained in their possession and was not yet repaired. The failure mileage was approximately 185,000.

Apr 20, 2022

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE THE VEHICLE WAS STATIONARY OR WHILE DRIVING VARIOUS SPEEDS, THE ODOR OF EXHAUST FUMES ENTERED THE CABIN OF THE VEHICLE. SUMMERVILLE FORD (9700 DORCHESTER RD, SUMMERVILLE, SC 29485, (877) 477-1434) WAS MADE AWARE OF THE FAILURE, BUT THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

Jul 03, 2018

+ 5 more complaints for this component

STEERING,SUSPENSION

7 complaints

The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 19V435000 (Suspension) and the vehicle was taken to the dealer for the recall repair. The contact stated that while driving out of the dealer lot, the steering failed to function as intended. The contact stated that the steering wheel was difficult to turn. The vehicle was diagnosed with steering gear and steering module failures. The contact was informed that the steering gear and the steering module needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact was informed that the repair was not covered under NHTSA Campaign Number: 14V286000 (Steering). The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was 110,304.

Jul 26, 2024

The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 21V746000 (Suspension). The contact stated that on two occasions while driving approximately 40 MPH, the steering wheel seized. The contact stated that the vehicle began jerking to the right. The vehicle was taken to a dealer where it was diagnosed that the steering rack needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 205,000.

Dec 01, 2023

The contact owns a 2011 Ford Explorer. The contact stated while reversing out of the driveway, the power steering failed, and the steering wheel became very difficult to turn in either direction. The vehicle was towed to the local service center who replaced the steering column and rear suspension tow link. Recently while driving approximately 40 MPH, the power steering failure reoccurred, and the warning message "Service Power Steering" was displayed. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was 180,000.

Jul 26, 2023

Hello, FORD in Woodbridge VA. I was driving with my daughter home. And all of a sudden the steering wheel locked or got really hard to turn. I was just a block away from home thank God so I immediately pulled over. The warning sign that came up said power steering. It was after hours so the next morning i called Ford to take my vehicle in for the recall and dropped it off. * I was told that although it's a recall it had expired so my claim was denied and the cost of repairs is $2700. I am outraged that a manufacture safety issue that's out of my control has an EXPIRATION date. There should NOT be expiration on something that has a recall on it. Not only did they tell me it's expired, regards to the repair, no discount was offered knowing they have that issues and when asked if I would be able to get a loaner veh during repairs they stated they couldn't provide me a loaner if my vehicle was under repairs as they don't provide loaners. When I asked for that in writing they then stated they just didn't have any loaners available. I could of killed someone, my myself or my child at how the steering wheel tightenocked up during my driving. My child has cerbal palsy, disabled and has therapy appts and certain needs each day that required me to have transportation. if my vehicle is under repairs, whether for recall or not I should be provided a loaner vehicle. I am not asking for coverage on wear and tear . Coverage on cosmetics. This is a known issue and I am being punished cuz it's "expired"? My car is in decent condition. Even though the car is over 10 year old, I have not had this vehicle for 10 years. It shouldn't be a expiration on major safety issues. And if 10 years is the date it should be 10 years from ownership. I haven't owned this vehicle for 10 years. This is not okay to charge money for issues the manufacturer know is a safety issue.

Oct 06, 2022

AS I WAS IN MOTION DRIVING MY SERVICE POWER STEERING LIGHT CAME ON AND ABOUT 30 SECONDS LATER I LOST ALL POWER STEERING CAUSING MY VEHICLE TO SWERVE TO THE LEFT. I WAS ABLE TO STOP THE VEHICLE. THE VEHICLE IHAS HAS THIS ISSUE OF LOOSING POWER STEERING IN THE PAST AUGUST OF 2019 AND THE POWER STEERING RACK WAS REPLACED FEBRUARY OF 2018. I HAVE TAKEN MY VEHICLE INTO THE LOCAL FORD DEALERSHIP IN 2019 AND WAS ADVISED IT NEEDED A NEW POWER STEERING RACK AT MY COST! I HAVE SINCE HAD THIS ISSUE AGAIN NOVEMBER 3RD. I HAVE CONTACTED FORD AND THE DEALERSHIP IN 2019 CREATED A FRAUD CLAIM FOR REPROGRAMING THE CLIMATE CONTROL MODULE NOTHING WITH THE ISSUE THAT I INITIALLY BROUGHT IN WITH. IM SCARED FOR THE SAFETY OF MY FAMILY IN THIS VEHICLE AND THE UNETHICAL CLAIM BARNES BAKER AUTOMOTIVE OF TRENTON, MO HAS CLAIMED. MY VEHICLE IS NOT SAFE TO DRIVE AT THIS TIME AND I HAVE CONCERNS THAT THE SUSPENSION RECALL HAS EVEN BEEN PREFORMED. THE RECALL FOR THE POWER STEERING HAS BEEN PERFORMED BUT, IS AN ONGOING PROBLEM FOR MY VEHICLE. FORD IS CLAIMING THIS IS NOT A RECALL RELATED ISSUE WHICH THIS VEHICLE HAS HAD A ONGOING P[ROBLEM WITH THE POWER STEERING LOCKING UP. THIS ALMOST CAUSED AN ACCIDENT!

Nov 05, 2020

+ 2 more complaints for this component

SUSPENSION

7 complaints

The contact owns a 2011 Ford Explorer. The contact stated that the vehicle was previously repaired at the dealer under NHTSA Campaign Number: 19V435000 (Suspension); however, the failure occurred after the recall repair was performed. The contact stated that while driving at an undisclosed speed, the vehicle made squeaking and popping sounds. The vehicle was taken back to the dealer, where it was diagnosed that the sway bar links needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 126,000.

May 11, 2023

The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 21V746000 (Suspension) however, the part to do the recall repair was unavailable. The vehicle was taken to the local dealer who stated the recall was not shown in the system. The contact stated the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was notified but no further assistance was provided. The contact had not experienced a failure. The VIN tool showed no open recall.

Feb 22, 2022

The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 21V746000 (Suspension) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The contact stated that there was a noise coming from the front of the vehicle. The local dealer and the manufacturer were not yet contacted. The failure mileage was unknown. VIN tool confirms parts not available.

Feb 17, 2022

MY SON WAS DRIVING AND MADE A U TURN ON A CITY STREET AND DURING THE END OF THE U TURN THE PASSENGER CONTROL ARM SNAPPED NEAREST TO THE WHEEL. THE CAR DID NOT HIT A CURB OR RUN OVER ANYTHING TO CAUSE THE BREAK. THE LOCAL POLICE DEPT, TOW TRUCK DRIVER AND MYSELF INSPECTED THE AREA AND THERE WAS NOTHING THAT WAS "HIT" TO CAUSE THIS. ONCE THE MECHANIC WAS ABLE TO LOOK AT THE CONTROL ARM WHEN IT WAS ON THE HOIST THEY POINTED OUT TO US THAT THE METAL CONTROL ARM WAS DEFECTIVE WHEN IT WAS CAST OR WASN'T FABRICATED CORRECTLY. THE METAL WAS LESS DENSE AND MORE HOLLOW ON ONE SIDE OF THE BREAK THAN THE OTHER SIDE. THE BREAK WAS A CLEAN BREAK WITHOUT JAGGED EDGES. THIS WAS THE CAUSE OF THE BROKEN CONTROL ARM. WE WHERE LUCKY SINCE MY SON DRIVES THE FREEWAY AT 65MPH SPEEDS ALMOST ON A DAILY BASIS AND IF THIS FRONT CONTROL ARM BROKE AT THOSE SPEEDS HE WOULD HAVE LOST CONTROL OF HIS CAR AND CAUSE A MAJOR ACCIDENT AND THERE COULD HAVE BEEN A LOSS OF LIFE. WE HAD ROUTINE MAINTENANCE WORK DONE ON THE CAR IN OCTOBER AND THE MECHANIC SAID HE SAW NOTHING WRONG WITH THE CAR THEN AND SUGGESTED THAT SINCE THE DRIVER SIDE CONTROL ARM WAS ALSO AN ORIGINAL PART AND PROBABLY CAST AT THE SAME TIME AND USING THE SAME METHODS THAT IT WAS ONLY A MATTER OF TIME BEFORE THE DRIVER SIDE CONTROL ARM GAVE OUT SIMILARLY. WE OPTED TO PAY THE ADDED COST TO REPLACE BOTH FRONT CONTROL ARMS SINCE OUR SON'S SAFETY IS PARAMOUNT.

Feb 13, 2020

ABOUT A YEAR AGO, WE NOTICED A SQUEAKY NOISE IN THE FRONT OF VEHICLE EACH TIME WE WOULD ACCELERATE, HIT A BUMP, OR MAKE A TURN. TOOK IT TO MY MECHANIC WHO REPLACED PARTS IN THE FRONT SUSPENSION OF THE VEHICLE. TOOK CARE OF MOST OF THE ISSUE BUT STILL OCCASIONALLY SQUEAKS AS WE BRAKE. I BELIEVE THERE IS AN ISSUE WITH THE FRONT SUSPENSION OF THIS VEHICLE.

Sep 04, 2019

+ 2 more complaints for this component

VISIBILITY

7 complaints

Windshield trim panels came loose and were slapping the drivers and passengers side windows. Read article in paper with 164 complaints. Cost me over $800 to replace

Feb 02, 2023

The contact owns a 2011 Ford Explorer. The contact stated while driving 55 mph, the sun roof exploded unexpectedly. There was no impact to the sun roof that could have caused it to shatter. The sun roof shards fell inside the vehicle onto the contact and her children however, there were no injuries sustained. The vehicle was taken to the dealer and diagnosed that the sun roof frame had separated and was defective. The vehicle was not repaired and remained at the dealer. The insurance company inspected the vehicle and concluded that it was a manufacturing defect. The manufacturer was made aware of the failure. The failure mileage was 120,000.

May 28, 2021

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT WATER FROM THE MOON ROOF CAUSED THE WINDSHIELD TO FREEZE. THE VEHICLE WAS TAKEN TO LEVITTOWN FORD (3195 HEMPSTEAD TURNPIKE, LEVITTOWN, NY 11756, (516) 336-4718), BUT WAS NOT DIAGNOSED OR REPAIRED DUE TO THE COST. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 47,800.

Dec 18, 2019

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE DRIVING AT AN UNKNOWN SPEED, THE AIR CONDITIONING UNIT FAILED ON THE PASSENGER SIDE. THE CONTACT MENTIONED THAT THE VEHICLE WAS BLOWING COLD AIR INSTEAD OF HOT AIR. THE VEHICLE WAS TAKEN TO AUTONATION FORD NORTH CANTON (5900 WHIPPLE AVE NW, NORTH CANTON, OH 44720 (330) 238-3206) WHERE IT WAS DIAGNOSED THAT THE AIR CONDITIONING MOTOR ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS ADVISED TO CONTACT NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 29,416. *BF CONSUMER STATED THE DEALERSHIP HAS LIST OF MANY OTHER CUSTOMERS WITH SIMILAR DEFECTIVE PARTS AND TV NEW STORY WITH SAME PROBLEM AND CONSUMER REPORT HAS RECORD OF POOR PARTS UPDATED 8/20/18*JB

Nov 15, 2017

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 60 MPH, THE CONTACT SAW A PIECE FLY OFF OF THE WINDSHIELD AND INTO TRAFFIC. THE CONTACT STOPPED TO INSPECT THE WINDSHIELD AND NOTICED THAT THE PLASTIC PIECE WAS CONNECTED TO THE PANEL OF THE WINDSHIELD. THE CONTACT CALLED ALL STAR LINCOLN FORD (17742 AIRLINE HWY, PRAIRIEVILLE, LA 70769, (225) 490-7645) WHERE THE DEALER STATED THAT THE VEHICLE WAS NOT COVERED UNDER WARRANTY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT TO TAKE A PHOTO OF THE WINDSHIELD AND TO SEND IT TO FORD CUSTOMER SERVICE. THE APPROXIMATE FAILURE MILEAGE WAS 78,000.

Jul 06, 2017

+ 2 more complaints for this component

SERVICE BRAKES

7 complaints

Entire braking system on this 2011 with only 140,000 miles apparently all failed simultaneously. Dealer required replacement of rear brake pads, rotors, calipers, brake booster, master cylinder and wanted to replace the entire ABS control assembly - which I declined. Brakes had a "soft pedal" when I took it into the dealership and when I left the dealer apparently sabotaged the brake system as it was undrivable at that point. Dealer even requested I waive my rights prior to taking the vehicle (see attached). It appears Ford manufactured a vehicle that their own technicians can't figure out to properly repair without replacing the entire system that fails with low miles.

Mar 16, 2022

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED WHILE HIS WIFE WAS DRIVING AT 35 MPH, THE BRAKE PEDAL HAD TO BE PUMPED SEVERAL TIMES BEFORE THE VEHICLE CAME TO A STOP. THERE WERE NO WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND WAS INFORMED THE EXTENDED TRAVEL PLAY NEEDED TO BE REPLACED. THE CONTACT STATED THAT THE BRAKES WERE REPLACED TWICE HOWEVER, THE VEHICLE STILL EXPERIENCED THE FAILURE. THE VEHICLE WAS TAKEN TO LOCAL DEALER (SHAWNEE MISSION FORD LOCATED AT 11501 SHAWNEE MISSION PKWY, SHAWNEE, KS 66203), AND THE SERVICE MANAGER WAS INFORMED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER HAD BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 140,000. THE VIN WAS NOT AVAILABLE.

Jan 29, 2020

RIGHT REAR BRAKE CALIPER SEIZED, CREATING SMOKE AND EXTREME HEAT TO WHEEL AREA. CALIPER REPLACED UNDER WARRANTY. SAME ISSUE WITH LEFT REAR CALIPER ON 5-1-15 AT 42K MILES. LEFT CALIPER REPLACED AT MY EXPENSE, AS IT WAS OUTSIDE THE WARRANTY PERIOD. SAME ISSUE WITH RIGHT REAR CALIPER AGAIN ON 5-26-15 AT 44K MILES. DEALERSHIP SAID THAT THE CALIPER WAS OK AFTER CLEANING THE AREA. THERE APPEARS TO BE CONTINUAL PROBLEM WITH THESE REAR BRAKES ON BOTH SIDES.

May 31, 2015

BOTH REAR BRAKE CALIPERS ARE SEIZED. I NOTICED THE PROBLEM ONLY WHEN THE BRAKE PADS HAD WORN DOWN TO METAL ON METAL AND WERE CAUSING A GRINDING NOISE. I'VE OWNED THE VEHICLE FOR LESS THAN A YEAR AND BOUGHT IT FROM A DEALERSHIP. *TR

Apr 24, 2015

LEFT REAR BRAKE CALIPER FAILED CAUSING VEHICLE TO BECOME UNSTABLE FOR BRIEF SECOND WHEN THE CALIPER GRABBED THE ROTOR WHILE TRAVELING AT HIGHWAY SPEEDS. YOU COULD FEEL THIS IN THE STEERING AND WOULD HAVE TO CORRECT AT EACH DIP OR BUMP IN THE HIGHWAY. BRAKE PAD WORN TO FAILURE POINT BEFORE IDENTIFYING THE PROBLEM. *TR

Aug 24, 2014

+ 2 more complaints for this component

POWER TRAIN,ENGINE

6 complaints

Every time we put the car in park, it would not register that it was in park and warning kept flashing that said shift to park. We had to just turn off the car most of the time and sometimes wiggling the shifter would work any time the "Not in Park" sign comes on when I know the gear is in park. I believe this can cause serious damage to property or cause death since the vehicle can roll. I believe Ford Motor Co should own up and recall all vehicles for service much for This is a known problem that has been know to happen to 2011 Edge and Explorers. The switch in the console shifter tends to fail prematurely. If the light does not light up the computer thinks the car is NOT in Park and alarms go off. THIS NEEDS TO BE FIXED BY FORD THIS IS A SAFETY ISSUE

Mar 21, 2022

WENT TO GO DRIVE THE SUV WHILE DOING ONLY 25 MPH & IT WAS RAVING OUR 3-5 RPM. WHILE DRUG IN THE CITY

Mar 16, 2017

HAVE EXTENSIVE ENGINE DAMAGE DUE TO WATER PUMP FAILURE WITH NO WARNING! I WAS DRIVING MY VEHICLE DOWN A MAIN HIGHWAY AND ALL OF A SUDDEN THE "ENGINE COOLANT OVERTEMP" CAME ON THEN "LOW OIL PRESSURE" AND MY VEHICLE SHUT DOWN! I COULDN'T DRIVE THE VEHICLE. LUCKILY I DRIFTED TO SIDE OF THE ROAD SO THAT MY CAR COULD BE TOWED WITHOUT HAVING AN ACCIDENT! SHOP DETERMINED WATER PUMP FAILURE AND WATER LEAKED INTO MY ENGINE POOR ENGINE DESIGN ON FORDS PART) AND DESTROYED THE ENGINE WITH NO WARNING! NO ENGINE LIGHT CAME ON OR ANYTHING. PLEASE INVESTIGATE THIS. THERE ARE NUMEROUS COMPLAINTS ABOUT THIS SAME SITUATION. I CALLED FORD TO COMPLAIN BUT ALL THEY DID WAS TAKE DOWN MY COMPLIANT. THIS IS A SAFETY ISSUE BECAUSE I WAS DRIVING IN TRAFFIC AND THIS COULD HAVE CAUSED AN ACCIDENT. THE WHOLE CAR JUST SHUT DOWN! *TR

Nov 02, 2016

I WAS LEAVING MY HOUSE PULLING A KAYAK TRAILER WITH ONE KAYAK ON IT, WENT ABOUT A HALF BLOCK AND THE ENGINE SLOWED DOWN AND THE FORD EXPLORER WOULD HARDLY MOVE. WAS ABLE TO GO AROUND THE BLOCK AND MAKE IT BACK TO MY DRIVEWAY. AFTER STOPPING AND RESTARTING THE PROBLEM WAS GONE. I HAD THE FORD EXPLORER TOWED TO THE DEALER WERE I BOUGHT IT, THEY CHECKED IT AND SAID IT DIDN'T SHOW A ERROR CODE ON THE COMPUTER AND DROVE IT TWICE AND COULD NOT MAKE IT HAPPEN SO THERE WAS NOTHING THEY COULD DO. I RESEARCHED THE PROBLEM AND FOUND OUT IT IS THE ELECTRONIC THROTTLE BODY AND THEY HAVE CHANGED OVER ONE MILLION OF THEM. BOTH YOU AND FORD ARE AWARE OF THE PROBLEM BUT A RECALL WAS NEVER ISSUED. ALSO ONCE THIS HAPPENS IT WILL HAPPEN AGAIN UNTIL THE PROBLEM IS FIXED. I HAVE A VEHICLE WITH 38 THOUSAND MILES ON IT THAT IS UNSAFE TO DRIVE AND CANNOT GET IT FIXED.

Jun 25, 2016

WHILE DRIVING THE CAR DIES AND THE YELLOW WRENCH LIGHT APPEARS. THIS OCCURRED TWICE IN ONE DAY. THE FIRST TIME IT OCCURRED I WAS JUST BEGINNING TO ACCELERATE. I WAS ABLE TO PULL OVER AND RESTART THE CAR. THE SECOND INCIDENT OCCURRED WHILE DRIVING DOWN THE HIGHWAY. I WAS ABLE TO PULL OVER AND RESTART THE CAR. I IMMEDIATELY BROUGHT IT TO A FORD DEALER WHO HAS HAD THE CAR FOR THREE DAYS AND CANNOT FIND OUT WHAT IS WRONG. *JS

Aug 31, 2013

+ 1 more complaint for this component

UNKNOWN OR OTHER,ENGINE

6 complaints

THE INTERIOR OF THE VEHICLE SMELLS OF SMOG/GAS AFTER JUST A FEW MINUTES OF DRIVING AND CAUSES HEADACHES FOR ME AND MY KIDS

May 12, 2021

CAR TURNED OFF AS I WAS SLOWING DOWN FOR A TRAFFIC LIGHT. PANEL READ " NO POWER TO ENGINE" OR SOMETHING TO THE EFFECT. WAS NOT ABLE TO TAKE A PHOTO OF PANEL DUE TO I WAS CAUGHT IN TRAFFIC WITH CARS BEHIND ME.

Mar 27, 2019

STRONG ENGINE EXHAUST SMELL IN VEHICLE CABIN WHILE DRIVING, DURING ENGINE OPERATION ABOVE 3000-3500 RPM WITH WINDOWS CLOSED AND CLIMATE CONTROL ON. OUTSIDE AIR ON OR OFF SEEMS TO MAKE NO DIFFERENCE.

Feb 15, 2017

WHILE DRIVING AND ESPECIALLY AFTER, THERE IS A BURNING HAIR SMELL THAT IS IN THE CAR AND WHEN YOU STEP OUTSIDE THE CAR IT IS VERY STRONG IN THE ENGINE. UPON LEARNING OF THE CLASS ACTION LAWSUIT TOO LATE, IT HELPED MAKE SENSE WHY I WAS SMELLING THE "BURNT HAIR" SMELL WHEN I RAN THE HEATER AND/OR AC. THIS WAS ANYTIME I DROVE THE CAR WHETHER HIGHWAY DRIVING OR AROUND TOWN.

Feb 14, 2017

EXHAUST FUMES ENTER THE PASSENGER COMPARTMENT WHEN THE AC IS RUNNING AT HIGHWAY SPEEDS AND AT ANY SPEED WHEN THE ENGINE IS TAXING IE GOING UP A STEEP GRADE.

Aug 24, 2016

+ 1 more complaint for this component

AIR BAGS,SEAT BELTS

5 complaints

The airbag warning light keeps coming on after continued checks and fixes. The dealership zip tied connector c211 and the light went off for a bit then came back on, the seat belt has been replaced but the light came back on, and all other components have been checked but no matter what the fix the light stays on. This is an issue many people have and Ford should be responsible for fixing it.

Mar 21, 2024

MY AIR BAG CONTROL LIGHT CAME ON 3 YEARS, I TOOK THE VEHICLE TO THE FORD DEALERSHIP A D THEY DISCOVERED THE SEAT BELT PRETENSIONER HAD SHORTED OUT. IT WAS REPLACED AT MY EXPENSE. FAST FORWARD TO TODAY AND THE SAME LIGHT IS BACK ON FOR WHAT I IMAGINE IS THE SEAT BELT PRETENSIONER AGAIN! THE LIGHT STAYS ON FROM THE TIME THE CAR IS STARTED TILL IT'S TURNED OFF.

Nov 03, 2020

RESTRAINTS INDICATOR LAMP WARNING LIGHT CAME ON AND WON'T GO OFF. I HAVE AN APPOINTMENT SETUP THIS FRIDAY WITH MY LOCAL FORD DEALERSHIP TO HAVE IT CHECKED OUT, BUT WHEN I RESEARCHED THE ISSUE, I FOUND THAT A TON OF PEOPLE HAD THE SAME PROBLEM. A MAJORITY WERE RESOLVED BY FIXING A CONNECTION UNDER THE DRIVER SEAT.

Jul 26, 2017

DIAGNOSE AND ADVISED THAT DRIVER PRETENSIONER IS FAULTY. I HAVE TO PAY $400 PLUS TO HAVE THIS REPLACEMENT. MY AIR BAG LIGHT IS ALWAYS ON WITH FAULTY PRETENSIONER IT MAY NOT GO OFF IN AN ACCIDENT.

Dec 20, 2016

A SEAT BELT/AIR BAG WARNING LIGHT HAS BEEN COMING ON INTERMITTENTLY. I WAS TOLD THAT THE SERVICE DEALERS COULD ONLY INVESTIGATE THIS WHEN THE LIGHT WAS ON. AS IT COMES AND GOES, I HAVE NOT BEEN ABLE TO TAKE THE VEHICLE INTO THE DEALER FOR A COUPLE OF MONTHS. WHEN I DID, I WAS TOLD THAT IT WAS NO LONGER IN WARRANTY AND I WOULD BE CHARGED ABOUT $450. THE REPRESENTATIVE SAID IF I DID NOT GET IS CORRECTED THAT THE AIR BAG WOULD NOT WORK PROPERLY THEREBY EXPOSING ME TO RISK. IT SEEMS THAT A SITUATION SUCH AS THIS SHOULD BE COVERED BY THE MANUFACTURER INDEFINITELY OR ARE THEY WILLING TO TAKE THE CHANCE THAT THEIR CUSTOMERS WILL NOT BE INJURED FOR AN ERROR ON THEIR PART IN MANUFACTURE. I HAD THE DEFECT REPAIRED AT MY EXPENSE BUT WOULD LIKE TO HAVE AN INVESTIGATION OPENED AND POSSIBLE CHARGES AGAINST FORD MOTOR COMPANY AND POSSIBLY EVEN THEIR DEALERSHIP NETWORK.

Mar 04, 2014

VISIBILITY/WIPER

5 complaints

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT THE AFTER STARTING THE VEHICLE THE FRONT WINDSHIELD WIPERS INDEPENDENTLY ACTIVATED CAUSING A VISIBILITY HAZARD TO THE DRIVER. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER SAM SCISM MOTORS (5019 FLAT RIVER RD., FARMINGTON MO) AND THE MANUFACTURER WERE BOTH NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 170,000.

Jan 27, 2020

ALL OF THE WINDSHIELD TOP MOLDING AND HALF THE RIGHT SIDE HAS BLOWN OUT OVER LAST 2 HIGHWAY TRIPS. WINDSHIELD IS ORIGINAL AND HAS NEVER BEEN WORKED ON. USUALLY OCCURRS AT SPEEDS OF 60 MPH OR ABOVE

Aug 15, 2017

I HAD STARTED THE CAR BEFORE OUR TRIP WITH THE REMOST START AND IT WARMED UP FOR 10 MINUTES. WE WERE ABOUT 15 MINUTES INTO OUR TRIP AND DRIVING DOWN THE I-96 EXPRESSWAY IN GRAND RAPIDS, MI NEAR EXIT 43 (28TH STREET), 65 MPH, 9:45PM, 32-33 DEGREES OUTSIDE AND RAINING, REAR WINDOW DEFROSTER ON AS WELL AS AUTO TEMP CONTROL AT 70 DEGREES. ALL OF A SUDDEN THE REAR WINDOW LOUDLY EXPLODES INWARDS AND SHOWERS OUR 10 YEAR OLD DAUGHTER WITH GLASS (SHE WAS THE ONLY PASSENGER IN THE THIRD ROW) AS WELL AS INTO THE PASSENGER COMPARTMENT. IMMEDIATELY PULLED OFF THE HIGHWAY AT THE NEXT EXIT, THERE WAS NO SIGN OF IMPACT, NO SNOW OR ICE IN THE CAR, NO ROCKS, NO BULLETS. WHERE IT OCCURRED THERE WERE NO OVERPASS OR SIGNS OVER THE ROAD (NOTHING COULD HAVE FALLEN ON OUR CAR). AFTER INSPECTING THE WINDOW, IT WAS APPARENT THAT THE WHOLE WINDOW WAS SHATTERED WITH A LARGE GAPING HOLE IN THE LOWER MIDDLE (12" X 18") WITH MOST OF THAT GLASS IN THE PASSENGER COMPARTMENT. THE REAR WINDSHIELD WIPER HAD CAME THROUGH THE HOLE AND WAS INSIDE THE CAR (BUT STILL ATTACHED TO ITS OUTSIDE POSITION). THE EDGES ON BOTH SIDES OF THE REAR WINDOW HAD BROKEN OFF. *TR

Dec 26, 2016

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 60 MPH, THE FRONT EXTERIOR DRIVER SIDE WINDSHIELD PANEL DETACHED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.

Oct 19, 2015

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH, THE CONTACT HEARD A HISSING NOISE COMING FROM THE FRONT PASSENGER SIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE A-PILLARS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 18,500.

Mar 19, 2015

SEATS

5 complaints

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT THE PASSENGER HEATED SEAT WAS ACTIVATED AND IT BURNED A HOLE THROUGH THE SEAT ON TWO SEPARATE OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER AND THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 12,000 AND THE CURRENT MILEAGE IS 28,261. UPDATED 01/07/14*LJ UPDATED 1/22/2014 *JS UPDATED 03/17/15*LJ THE CONSUMER REQUESTED TO HAVE THE CASE RE-EVALUATED. UPDATED 8/18/2015*JS

Nov 01, 2013

Fire: 1

SINCE I PURCHASED MY EXPLORER IN APRIL 2011, I HAVE HAD TO SEE MY DOCTOR FOR VERY EXTREME LOWER BACK PAINS, I ALSO HAVE TO GO WEEKLY FOR CHIROPRATIC CARE, ACUPUNCTURE AND TRACTION FOR STRETCHING THE VERTEBRAE IN MY BACK. THE NERVES ARE CONSTANTLY PINCHING AND CAUSE SHARP PAINS THROUGHOUT THE DAY AND NIGHT. I AM NEARLY DISABLED BECAUSE OF THESE SEATS. I CANNOT WORK DUE TO THE PAIN AND FEAR I WILL BECOME PERMANENTLY DISABLED VERY SOON. THIS IS MY ONLY CAR, SO IT MUST BE REMEDIED A.S.A.P.. I HAVE DRIVEN MY DAUGHTERS BORROWED CAR AND HAVE NO PAINS ASSOCIATED WITH ANY OTHER VEHICLES I DRIVE. *KB

Nov 30, 2011

ARM RESTS FOR DRIVER'S SEAT TOO FAR FROM SEAT, ESPECIALLY ON THE LEFT, AND PROVIDE NO SUPPORT. NOT A PROBLEM FOR LOCAL DRIVING BUT ON LONG TRIPS CAUSES ARM FATIGUE. *KB

Jul 05, 2011

THE ACUTE ANGLE ON FORD EXPEDITION ARE UNSAFE AND CAUSE SEVERE MUSCLE FATIGUE AND STRESS. FORD PROVIDES NO EXPLANATION AS TO THEIR PURPOSE, NOR DO THEY PROVIDE ANY GUIDELINES AS TO THE PROPER ADJUSTMENT OR FIT. I AM NOT ONLY ANGRY AND DISAPPOINTED AT FORD BUT ALSO THE GOVERNMENT. WHERE ARE YOU GUYS? WHAT ARE YOU DOING WITH ALL THE TAX MONEY WE'RE SENDING YOU? WHERE'S THE TESTING AND OVERSIGHT? PS YOU DID NOT INCLUDE THE FORD EXPEDITION IN YOUR LISTS SO I HAD TO CHOOSE THE EXPLORER. I CAN'T BELIEVE THIS. *TR

Jun 25, 2011

LEAR CORPORATION AND FORD ALREADY KNEW THAT A SPACER/WASHER WAS LEFT OFF THE EXPLORER BY THREE ROTATING LEAR EMPLOYEES ON THE NIGHT SHIFT. THESE EMPLOYEES WERE NOT PENALIZED IN ANY WAY. THE SHIFT STINKS OF NEPOTISM AND EVERY OTHER EOE/EEO MISDEED. OTHER EMPLOYEES, NOT MEETING NUMBERS(NOT QUALITY ISSUES) ARE BEING WALKED OUT. THIS LEAR FACILITY, IN HAMMOND, INDIANA, RECEIVES A $5000 FEDERAL TAX CREDIT FOR EACH NEW W2 FORM TURNED IN. *TR

Feb 08, 2011

STEERING,ENGINE AND ENGINE COOLING

4 complaints

See attached document for complaint

Mar 11, 2025

MY FORD EXPLORER 2011 OMITS A FOUL ODOR(SMELLS LIKE ROTTEN EGG)WHEN YOU TURN ON THE AC WHILE DRIVING, THE STEERING COLUMN FEELS LOOSE AND HAS A STRONG WIND NOISE WHILE DRIVING. *TR

Oct 31, 2016

POWER STEERING ASSIST DISABLED AND ASSOCIATED WARNING LIGHT ENABLED. VEHICLE HAD BEEN STOPPED WITH ENGINE RUNNING AND IN GEAR. DISABLE OCCURRED WHEN I STARTED TO MOVE FORWARD. PROBLEM CORRECTED ITSELF AFTER TURNING OFF AND RESTARTING VEHICLE. CONTINUED TO DRIVE VEHICLE. OCCURRED A SECOND TIME, APPROXIMATELY 1 WEEK LATER, WHILE TURNING INTO A PARKING SPACE. POWER STEERING WAS AGAIN ENABLED BY TURNING OFF AND RESTARTING ENGINE. PARKED VEHICLE IN GARAGE FOR ABOUT 1 WEEK UNTIL IT WAS DRIVEN TO THE DEALER WHERE DIAGNOSIS WAS STEERING GEAR NEEDED REPLACING. NO REPAIR PERFORMED TO DATE, APPROXIMATELY 3 WEEKS LATER. REPORTEDLY THE PART IS ON BACK ORDER. *TR

Oct 02, 2012

POWER STEERING FAILED WHILE DRIVING. TRACTION ASSIST CONTROL ALSO FAILED AT THE SAME TIME. SHUTTING THE ENGINE OFF AND RESTARTING BROUGHT THE POWER STEERING BACK BUT NOT THE TRACTION CONTROL. THE TRACTION CONTROL BEGAN FUNCTIONING AGAIN AFTER THE TRUCK SAT FOR ABOUT 8 HOURS. *TR

Jun 28, 2012

ENGINE AND ENGINE COOLING,ENGINE

4 complaints

The contact owns a 2011 Ford Explorer. The contact stated that the low oil pressure warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the engine block was cracked and the oil sending unit was damaged. The dealer informed the contact that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under warranty. The failure mileage was approximately 122,000.

Feb 06, 2024

The contact owns a 2011 Ford Explorer. The contact stated that while driving approximately 35 MPH while turning right and exiting a ramp, then when idle a message stated "Low Oil Pressure" illuminated on the instrument panel. Shortly after the vehicle lost motive power. A certified mechanic inspected the vehicle and diagnosed that the camshaft sensor needed to be replaced. The vehicle was repaired. The failure reoccurred while test-driving the vehicle to determine if the repair was successful. The vehicle was re-examined and diagnosed that the water pump had failed causing the engine coolant and oil into the engine causing the engine to seize completely. The engine needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure and referred them to the NHTSA Hotline. The approximate failure mileage was 152,000.

Oct 10, 2023

The contact owns a 2011 Ford Explorer. The contact stated that while his wife was driving at an undisclosed speed, the vehicle stalled without warning. The contact’s wife notified the contact, and the contact was able to coast the vehicle off the road. The contact then stated that he allowed the vehicle to cool down, restarted the vehicle, then coasted the vehicle to his residence. The vehicle was then towed to the dealer where it was diagnosed that the water pump failed and caused the coolant to leak into the engine and damaged the engine and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was provided a case number, but no further assistance was provided. The failure mileage was approximately 173,000.

May 01, 2023

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT A STRONG FUEL ODOR WAS PRESENT IN THE VEHICLE. THE VEHICLE WAS TAKEN TO A LOCAL DEALER, LEVITTOWN FORD LLC 3195 HEMPSTEAD TURNPIKE, LEVITTOWN, NY 11756, WHERE IT WAS DETERMINED THAT EXHAUST FUMES WERE PRESENT IN THE REAR OF THE VEHICLE. THE CONTACT STATED THAT THE FAILURE WAS PERSISTENT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT A LITIGATION WAS CURRENTLY PENDING. THE FAILURE MILEAGE WAS APPROXIMATELY 35,000. UPDATED 11/13/17 *BF UPDATED 11/16/2017*JS

Aug 01, 2017

STEERING,SERVICE BRAKES

4 complaints

RECALL EXPIRED WAS ALSO TOLD WARRANTY FOR RECALL EXPIRED(WAS TOLD ON PHONE THEY DIDN'T KNOW IF WARRANTY WOULD COVER UNTIL THEY RUN TEST IT THEN WAS TOLD IT EXPIRED) IN FEB I LOSS POWER STEERING AND A CLUSTER OF LIGHTS CAME ON DASH. HAPPENED IN FEB BUT CALLED AND SCHEDULED AN APPOINTMENT W FORD ON 3/1 BUT THEY DIDN'T HAVE AVAILABLE OPENING UNTIL THE FOLLOWING WEEK WE TOOK IT IN AND OF COURSE THEY SAY IT'S NOT COVERED. THIS IS BIG SAFETY ISSUES AND LOSS IT IN CURVE WHICH WAS SCARY. I DIDN'T PURCHASE CAR UNTIL 2017 SO NEVER HEARD OF RECALL AND SAME DEALER FIXED ANOTHER RECALL SO WHY DID THEY NOT FIX THIS RECALL AT THAT TIME OR MENTION THIS.

Mar 16, 2021

Crash: 1

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 10 MPH AND MAKING A LEFT TURN, THE STEERING WHEEL AND BRAKING SYSTEM SEIZED AND WOULD NOT FUNCTION. THE CONTACT SHUT THE ENGINE OFF AND RESTARTED THE VEHICLE. AFTER RESTARTING THE VEHICLE THE STEERING AND BRAKING SYSTEMS FUNCTIONED NORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THAT THE STEERING UNIT WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE PERSISTED. THE CONTACT STATED THAT THE VEHICLE EXHIBITED A CLUNKING NOISE WHEN TURNING THE STEERING WHEEL. IN ADDITION, THERE WAS AN INVESTIGATION UNDER NHTSA ACTION NUMBER: PE12017 (STEERING:ELECTRIC POWER ASSIST SYSTEM) THAT COULD HAVE BEEN RELATED TO THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 3,000.

Dec 20, 2012

BRAKES MAKE A GRUNTING/GRINDING SOUND WHEN BRAKING SHORTLY AFTER BEING STATIONARY. WHEN THIS PHENOMENON HAPPENS ON A DOWNWARD SLOPE, DRIVE GETS THE FEELING THAT BRAKE EFFECTIVENESS IS REDUCED GREATLY. OWNER HAS BROUGHT CAR TO DEALER A TOTAL OF 4 TIMES AND WAS ABLE TO REPLICATE NOISE ONE TIME. *TR

Oct 19, 2012

PLEASE BE ADVISED THAT THE AFORE NOTED VEHICLE, ON JUNE 7TH , 2012 ON OR ABOUT 5PM WAS INVOLVED IN A SINGLE VEHICLE ACCIDENT ON ROUTE 63 AT MT WASHINGTON, ST. CROIX. SHE WAS TRAVELLING SOUTHWARD ON ROUTE 63 CROSSING THE SMALL BRIDGE ENTERING A SHARP RIGHT HAND TURN IN THE ROAD. SHE EXPERIENCED A SUDDEN, INSTANTANEOUS, LOSS OF RESPONSE IN THE STEERING AND BRAKING OF THE VEHICLE. AS A CONSEQUENCE, IN THE FEW SECONDS FOLLOWING, THE VEHICLE LEFT THE ROADWAY AND STRUCK A WOODEN UTILITY POLE. *TT

Jun 22, 2012

Crash: 1

Injuries: 1

WHEELS

4 complaints

ON FEBRUARY 14, 2021 WHILE CHECKING TIRE PRESSURES OF MY 4 COOPER ADVENTURER H/T CUV 245/60R18 TIRES. I NOTICED NUMEROUS SPLITTING OF THE LOWER SIDEWALL, AROUND THE BEADS OF ALL 4 TIRES. THIS IS NOT NORMAL DRY ROT / CRACKING OF THE LOWER SIDEWALL. THE SPLITTING OF THE SIDEWALLS HAVE GAPS FROM 1/16TH TO 1/8TH OF AN INCH WIDE. THE GAPS ARE 2 - 3/32NDS OF AN INCH DEEP. THE DOT #'S OF ALL 4 TIRES ARE UP83 1HT 4117. THE TIRES WERE INSTALLED AROUND THE BEGINNING OF 2018. THE TIRES HAVE APPROX. 25K MILES ON THEM. COOPER TIRES / PEP BOYS HAVE A 65K WARRANTY ON THESE TIRES. THERE IS APPROX. 7 - 9/32NDS OF THREAD LEFT ON ALL 4 TIRES. JUNE 5, 2019 COOPER TIRES ISSUED A SAFETY RECALL ON THIS EXACT MODEL TIRE BUT IN A DIFFERENT SIZE. THE TIRE SIZE IN THIS RECALL IS 235/65R18. FEBRUARY 26, 2021 COOPER TIRES HAS ISSUED YET ANOTHER SAFETY RECALL ON THIS EXACT MODEL TIRE BUT IN A DIFFERENT SIZE. THE TIRE SIZE IN THIS RECALL IS 275/65R18. BOTH, JUNE 5, 2019 AND FEBRUARY 26, 2021 RECALLS OF THE COOPER ADVENTURER H/T CUV TIRES WERE ISSUED DUE TO MANUFACTURING DEFECTS OF THE LOWER SIDEWALL. THE 4 COOPER ADVENTURER H/T CUV 245/60R18 INSTALLED ON MY VEHICLE HAVE VERY SIMILAR LOWER SIDEWALL DEFECTS, AS BOTH OF THE ISSUED RECALLS FOR THIS EXACT SAME TIRE MODEL. I FEEL THAT THE SPLITTING OF MY TIRES ARE A SAFETY HAZARD DUE TO MANUFACTURING DEFECTS. I WOULD LIKE TO HAVE MY 245/60R18 COOPER ADVENTURER H/T CUV TIRES, AS WELL AS ALL OF THE OTHER SIZES OF THIS MODEL TIRE MADE BY COOPER, ADDED TO SAFETY RECALL TIRE LIST.

Mar 04, 2021

ON FEBRUARY 14, 2021 WHILE CHECKING TIRE PRESSURES OF MY 4 COOPER ADVENTURER H/T CUV 245/60R18 TIRES. I NOTICED NUMEROUS SPLITTING OF THE LOWER SIDEWALL, AROUND THE BEADS OF ALL 4 TIRES. THIS IS NOT NORMAL DRY ROT / CRACKING OF THE LOWER SIDEWALL. THE SPLITTING OF THE SIDEWALLS HAVE GAPS FROM 1/16TH TO 1/8TH OF AN INCH WIDE. THE GAPS ARE 2 - 3/32NDS OF AN INCH DEEP. THE DOT #'S OF ALL 4 TIRES ARE UP83 1HT 4117. THE TIRES WERE INSTALLED AROUND THE BEGINNING OF 2018. THE TIRES HAVE APPROX. 25K MILES ON THEM. COOPER TIRES / PEP BOYS HAVE A 65K WARRANTY ON THESE TIRES. THERE IS APPROX. 7 - 9/32NDS OF THREAD LEFT ON ALL 4 TIRES. JUNE 5, 2019 COOPER TIRES ISSUED A SAFETY RECALL ON THIS EXACT MODEL TIRE BUT IN A DIFFERENT SIZE. THE TIRE SIZE IN THIS RECALL IS 235/65R18. FEBRUARY 26, 2021 COOPER TIRES HAS ISSUED YET ANOTHER SAFETY RECALL ON THIS EXACT MODEL TIRE BUT IN A DIFFERENT SIZE. THE TIRE SIZE IN THIS RECALL IS 275/65R18. BOTH, JUNE 5, 2019 AND FEBRUARY 26, 2021 RECALLS OF THE COOPER ADVENTURER H/T CUV TIRES WERE ISSUED DUE TO MANUFACTURING DEFECTS OF THE LOWER SIDEWALL. THE 4 COOPER ADVENTURER H/T CUV 245/60R18 INSTALLED ON MY VEHICLE HAVE VERY SIMILAR LOWER SIDEWALL DEFECTS, AS BOTH OF THE ISSUED RECALLS FOR THIS EXACT SAME TIRE MODEL. I WOULD LIKE TO HAVE MY 245/60R18 COOPER ADVENTURER H/T CUV TIRES ADDED TO THE SAFETY RECALL TIRE LIST. THIS MODEL TIRE SHOULD BE UNDER REVIEW FOR ALL MANUFACTURED SIZES.

Mar 03, 2021

ON FEBRUARY 14, 2021 WHILE CHECKING TIRE PRESSURES OF MY 4 COOPER ADVENTURER H/T CUV 245/60R18 TIRES. I NOTICED NUMEROUS SPLITTING OF THE LOWER SIDEWALL, AROUND THE BEADS OF ALL 4 TIRES. THIS IS NOT NORMAL DRY ROT / CRACKING OF THE LOWER SIDEWALL. THE SPLITTING OF THE SIDEWALLS HAVE GAPS FROM 1/16TH TO 1/8TH OF AN INCH WIDE. THE GAPS ARE 2 - 3/32NDS OF AN INCH DEEP. THE DOT #'S OF ALL 4 TIRES ARE UP83 1HT 4117. THE TIRES WERE INSTALLED AROUND THE BEGINNING OF 2018. THE TIRES HAVE APPROX. 25K MILES ON THEM. COOPER TIRES / PEP BOYS HAVE A 65K WARRANTY ON THESE TIRES. THERE IS APPROX. 7 - 9/32NDS OF THREAD LEFT ON ALL 4 TIRES. JUNE 5, 2019 COOPER TIRES ISSUED A SAFETY RECALL ON THIS EXACT MODEL TIRE BUT IN A DIFFERENT SIZE. THE TIRE SIZE IN THIS RECALL IS 235/65R18. FEBRUARY 26, 2021 COOPER TIRES HAS ISSUED YET ANOTHER SAFETY RECALL ON THIS EXACT MODEL TIRE BUT IN A DIFFERENT SIZE. THE TIRE SIZE IN THIS RECALL IS 275/65R18. BOTH, JUNE 5, 2019 AND FEBRUARY 26, 2021 RECALLS OF THE COOPER ADVENTURER H/T CUV TIRES WERE ISSUED DUE TO MANUFACTURING DEFECTS OF THE LOWER SIDEWALL. THE 4 COOPER ADVENTURER H/T CUV 245/60R18 INSTALLED ON MY VEHICLE HAVE VERY SIMILAR LOWER SIDEWALL DEFECTS, AS BOTH OF THE ISSUED RECALLS FOR THIS EXACT SAME TIRE MODEL. I WOULD LIKE TO HAVE MY 245/60R18 COOPER ADVENTURER H/T CUV ADDED TO THE SAFETY RECALL TIRE LIST. THIS MODEL TIRE SHOULD BE UNDER REVIEW FOR ALL SIZES THAT ARE MANUFACTURED.

Mar 03, 2021

2003 FORD EXPLORER XLT WHEEL BEARING HUBS ARE BAD AND IS A ON GOING ISSUE. *TR

Mar 08, 2011

VEHICLE SPEED CONTROL

4 complaints

VEHICLE EXPERIENCES UNINTENDED SUDDEN DECELERATIONS - WHEN DRIVING AT NORMAL SPEEDS THE VEHICLE WILL COAST TO A STOP, REGARDLESS OF THE AMOUNT THE GAS PEDAL IS DEPRESSED. TROUBLE CODES INDICATE THIS IS A COMMON PROBLEM DUE TO THE THROTTLE BODY ACTUATOR BEING FAULTY. DESPITE FORD EXTENDING THE WARRANTY FOR MULTIPLE OTHER VEHICLES WITH THE SAME ENGINE AND THROTTLE BODY, THEY DID NOT COVER THE EXPLORERS.

Sep 17, 2018

2011 FORD EXPLORER XLT: UPON RAPID ACCELERATION (EXAMPLE: ACCELERATING ONTO HIGHWAY VIA HIGHWAY ENTRANCE RAMP) VEHICLE LOOSES MOMENTUM THEN LURCHES FORWARD. VEHICLE IS NOT SMOOTHLY TRANSITIONING FROM LOWER GEARS TO HIGHER GEARS. VEHICLE PURCHASED FROM FORD DEALER, CERTIFIED USED WITH APPROXIMATELY 70,000 MILES. ISSUE OCCURRED AT APPROXIMATELY 90,000 MILES.

Oct 04, 2016

I HAVE EXPERIENCE TWICE THE SAME PROBLEM WITH THE THROTTLE OF THIS VEHICLE. I CHANGE THE PART ABOUT 7 MONTHS AGO AND HAD TO REPLACE IT AGAIN LAST WEEK. THE VEHICLE JUST DECREASES SPEED SUDDENLY TO ABOUT 5 MILES PER HOUR AND A LIGHT COME ON THE DASH WITH A WRENCH. THIS HAS HAPPEN TWICE ALREADY AND IT CAN CAUSE A SERIOUS ACCIDENT IF DRIVING AT A HIGHWAY. I WAS DRIVING ON A HIGHWAY AND LUCKLY I WAS ON THE INNER SIDE AND COULD PULL OVER BUT IF IT HAD HAPPEN ON THE OUTTER LANES THIS COULD HAVE CAUSE A SERIOUS ACCIDENT.

Jun 14, 2016

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE ACCELERATED INDEPENDENTLY, CAUSING THE CONTACT TO CRASH INTO A GARAGE. A POLICE REPORT WAS FILED AND THE CONTACT SUSTAINED MINOR INJURIES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE DUPLICATED. NO REPAIRS WERE MADE TO THE VEHICLE. THE CONTACT ALSO STATED THAT WHILE ACCELERATING, THE ENGINE RPMS WOULD INCREASE RAPIDLY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE WAS 23,500.

Dec 09, 2014

Crash: 1

Injuries: 1

UNKNOWN OR OTHER,ENGINE,FUEL/PROPULSION SYSTEM

4 complaints

I HAVE 2011 FORD EXPLORER, WHICH I TAKE INTO THE LOCAL FORD DEALERSHIP FOR MAINTENANCE REGULARLY. I HAVE HAD ME EXPLORER A LITTLE OVER 2 YEARS. EVER SINCE I PURCHASED MY EXPLORER AND I WOULD TAKE IT IN FOR MAINTENANCE, I WOULD TELL THEM I SMELL EXHAUST FUMES ON THE INSIDE OF MY VEHICLE. ONLY ONCE DID THEY CHECK IT FOR ME. AT THAT TIME, THEY SAID THE GUY COULDN'T SMELL ANYTHING. WELL, TODAY 8-24-17, I HAD TO TAKE IT IN FOR ANOTHER ISSUE. MY EXPLORER ENGINE WOULD COMPLETELY SHUT OFF WHEN I WOULD DECELERATE. NEEDLESS TO SAY THAT WAS A SERIOUS ISSUE WHILE DRIVING...THEY ARE REPAIRING TODAY. BUT, I ALSO ASK THEM TO CHECK FOR EXHAUST SMELLS ONCE AGAIN. WELL TODAY, I GUESS SOMEONE SMELLED THE EXHAUST BECAUSE THEY TOLD ME THEY COULD FIX IT AT A COST OVER $200.00. SAID IT WAS AN UPDATE FOR THE EXHAUST MODULE OR SOMETHING LIKE THAT. I HAVE AN ISSUE WITH PAYING THAT, SINCE I KNOW THAT THERE HAS BEEN SEVERAL COMPLAINTS ABOUT THIS VERY ISSUE WITH MY MODEL OF FORD EXPLORER AND THAT THERE IS A CLASS ACTION LAWSUIT AGAINST FORD TO RESOLVE THIS ISSUE. THE REASON I KNOW THIS IS BECAUSE WHEN THEY INITIALLY SAID THEY DIDN'T SMELL ANYTHING I GOOGLED TO SEE IF ANYONE ELSE HAD THIS PROBLEM AND THEY DID. WHEN I ASK THE DEALERSHIP TODAY WHY I WOULD HAVE TO PAY THAT, THEY SAID BECAUSE MY VEHICLE IS NOT A POLICE VEHICLE AND THERE IS NO RECALL ON MY VEHICLE FOR THE EXHAUST PROBLEM. SO, I GUESS IF MY VEHICLE WAS A POLICE VEHICLE, IT WOULD BE REPAIRED BY FORD FOR FREE. POINT BLANK, I WOULD LIKE MY 2011 FORD EXPLORER REPAIRED BY FORD AT NO COST TO ME FOR THE EXHAUST PROBLEM.

Aug 24, 2017

SMELL OF EXHAUST FUMES INSIDE THE CABIN WHEN ACCELERATING HARD (IE, TO MERGE ON THE FREEWAY ETC). HAVE NOTICED THE ISSUE SINCE WE FIRST BOUGHT IT (USED) IN 2013).

Aug 02, 2017

UPON HEAVY ACCELERATION SUCH AS WHEN PULLING ONTO A HIGHWAY, OR PASSING ANOTHER VEHICLE ON THE ROAD, AN EXHAUST/FUEL SMELL WILL ENTER THE VEHICLE AND BE VERY NOTICEABLE TO EVERYONE IN THE VEHICLE. THIS OCCURS MOSTLY WHEN THE AIR CONDITIONER IS ON, ON RECIRCULATION. MY WIFE (PRIMARY DRIVER OF THIS 2011 FORD EXPLORER) COMPLAINS OF A LOT OF HEADACHES AND I AM BEGINNING TO WONDER IF SHE IS GETTING CARBON MONOXIDE POISONING FROM DRIVING THIS VEHICLE DAILY. WE ARE GOING TO BUY A CO2 DETECTOR TO SEE IF THIS IS IN FACT TRUE.

Sep 10, 2016

UNDER HARD ACCELERATION I GET A STING ODOR IN THE CABIN. IT IS LIKE AN EXHAUST SMELL INSIDE THE CAR. IT ALWAYS DOES IT ABOVE 3500 RPM.

Sep 23, 2015

STEERING,SUSPENSION,POWER TRAIN

3 complaints

I had a recall on my 2011 Ford explorer for toe Links and bushings. Since ever since this has been going on I have gone through 38 tires in the rear in the past two years alone no shop will fix my car because the camber is so out of whack I have to have the whole rear suspension redone again when it should have been fixed the first time with the recall link Ford spent 5 minutes going through my car and said that my car didn't qualify for any recall because my car is a front wheel drive and not an all-wheel drive so they did not do the recall now after bringing it to another shop I have the estimate of what it would cost to fix that needs to be done it is an emergency because when I hit a pothole I go in the ditch my friend and his smashed because I can't control my car my steering freezes while driving down the highway and this all has something to do with the rear suspension five Star automotive wrote down everything that needs to be replaced this is a hazard to be on the road, if I could afford another car I would have one I keep sinking money into this one, because of Link Ford and their mistake me and my car should not have to suffer for it or anyone else on the road because this is a hazard my car is going to kill someone if I would have had the recall replaced, I wouldn't have had to spend an additional $1,400 on parts and labor that never even got put in because they can't put them in until this is repaired I can't even get a front end alignment because of this the entire rear suspension is sagging to the ground and my tires tilt in about 42°. I have the printout from both Link Ford in mining and 5 star automotive in Superior WI because of the 22 times I've gone in the ditch due to my suspension and steering locking up I have a short in the ground wire somewhere that is now fried my ECU so when I put it in a $90 boot every time it lights on fire within 30 seconds I'm in closing that picture as well of the one I just put in little over an hour ago.

Oct 26, 2025

Crash: 1

When driving and get up to 60mph car shakes and moves side to side hard to control.

Apr 24, 2023

PLEASE REFERENCE PREVIOUS COMPLAINT CONFIRMATION NUMBER 10475098, SEPTEMBER 11, 2012. THE PROBLEM IS A COMPLETE LOSS OF POWER STEERING ASSIST THAT OCCURS INSTANTANEOUSLY, WITHOUT WARNING. THIS PROBLEM WAS SUPPOSEDLY REPAIRED BY MY FORD DEALER LAST FALL (SEPTEMBER, 2012) BY REPROGRAMMING A CONTROL UNIT. THE PROBLEM HAS NOW BEEN RECURRING AGAIN, ALMOST WEEKLY (THREE TIMES IN FOUR WEEKS). I FEEL THIS IS A VERY SERIOUS SAFETY ISSUE. DURING THE MOST RECENT INCIDENT, MY WIFE WAS DRIVING BY HERSELF. SHE DOES NOT HAVE THE STRENGTH TO DRIVE THIS CAR WITHOUT POWER STEERING ASSIST. LUCKILY SHE WAS TRAVELING IN A STRAIGHT LINE AND COULD BRING THE CAR TO A STOP. IF SHE HAD BEEN TURNING A CORNER OR ROUNDING A CURVE, SHE WOULD HAVE GONE OFF THE ROAD. I HAVE SEEN ON THE INTERNET THAT OTHER DRIVERS HAVE HAD THE SAME PROBLEM. I WILL TAKE THE CAR BACK TO THE DEALER, BUT FORD NEEDS TO OWN UP TO THIS PROBLEM AND FIGURE OUT A PERMANENT FIX. *TR

Aug 04, 2013

STEERING,ELECTRICAL SYSTEM,UNKNOWN OR OTHER

3 complaints

Over the past couple of years the steering wheel has locked. But would reset if turned off and on. The traction light also engaged temporarily and later went off. When I took my vehicle in to the dealership at Blue Springs Mo Ford on [XXX] for service and diagnostic they indicated a sensor and/or steering mechanism needed repair or replaced and the part has been on back order. They would order the parts-and let me know when they came in. They have yet to contact me on the part. They said it could be some time. . About a month the tire pressure sensor fault warning came on so I was looking repairs. Early this week while driving the power steering quit working. A day or so later while troubleshooting the dash display reported faults with both power steering assist and advance tract. After turning it back on and off the warning lights engaged. I have a new battery, checked connections and fuses, then looked online and found ford has a known problem with power steering assist failing. Also comments report if an issue occurs with the electronic power assist at any time Ford is responsible to repair for free. Today I called the ford number 800-392-3673 to report this problem and was informed my vehicle does not qualify for free repairs due to the mileage 173,958. The fix expired at 150,000 miles or 10 year - which was an extension to warranty). I don’t agree with this approach as Ford has been aware of this issue with the power steering electronic system for years and provided no notice to consumers. I would have had it checked prior to hitting the 150,000 mile mark. Please advise on my rights or recourse. Thanks. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Feb 01, 2024

"SERVICE POWER STEERING" WARNING LIGHT CAME ON, CODE WAS FOR LEFT STEERING CONTROL MODULE. ONE WEEK LATER, POWER STEERING WAS INTERMITTENT, THEN WENT OUT COMPLETELY. TOOK IN TO FORD DEALERSHIP, CODE FOR SAFETY RECALL 15N01 CAME UP, FORD DEALERSHIP SAYS MY VEHICLE IS COVERED UNDER RECALL BUT FORD MOTOR COMPANY REFUSES TO FIX, STATING "NO HOUSEHOLD LOYALTY", BECAUSE I'VE NOT PURCHASED A FORD BRAND NEW. WHEN CALLING FORD ABOUT THE ISSUE, THEY SAY THEY "WILL STAND BEHIND THE FORD DEALERAHIP IN THEIR DECISION"; YET NOW THAT THE DEALERSHIP IS READY TO FIX AND WAITING FOR THE AUTHORIZATION CODE FROM FMC, FMC WILL NOT STAND BEHIND THE DEALERSHIPS DECISION.

Jun 03, 2019

THE STEERING HAS NEVER WORKED CORRECTLY, SOMETHING JUST DOES NOT FEEL RIGHT WITH THIS VEHICLE. ALSO - THE SYNC SYSTEM DOES NOT WORK CORRECTLY AND THE SCREEN RANDOMLY REBOOTS AND IS NOT WORKING CORRECTLY. LASTLY THE CAR SYSTEM DOES NOT RECOGNIZE WHEN KEYS ARE IN THE CAR, SO EVERY TIME YOU GO TO START THE CAR DOES NOT WORK. HOW THIS IS UNSAFE - IS IN COLD WEATHER YOU HAVE YOUR KEYS IN HAND AND THE CAR WILL NOT START, WHICH MEANS YOU COULD BE LEFT IN THE COLD AND THE CAR WILL NOT START. THIS IS NOT SAFE.

Sep 19, 2016

STEERING,UNKNOWN OR OTHER

3 complaints

While driving my 2011 Ford Explorer at 60 mph I received a indicator stating service steering system soon. My concern was making sure I was able to still steer the vehicle to a safe location. I was still able to steer the vehicle and headed to the nearest parking lot to hopefully reset the system by restarting the vehicle. After parking I turned off the car and restarted it. After doing this the error came of service steering system now! Trying to steer the vehicle was extremely difficult. I proceeded home which is 30 min away and parked the vehicle until I could get it into a dealer. I did not call a tow truck as they are expensive and I know the repair was going to cost me a lot of money. The dealer verified the steering system was faulty and needed replaced. The steering system is electronically controlled and the failure of the system puts the occupants of the vehicle as risk of injury in the event the system failed and you need to move out of the way in an emergency or if I was not able to control the vehicle. The steering rack will be returned as part of the core charge for the replacement of the unit. Ford customer care told me this was a safety notice but is not a recall and it expired 10 yr after the warranty and vehicle over 150,000 miles. This should not be a notice but a recall as it seems there are a lot of failures. I should not have to pay money for something that is a known issue by the manufacture. The NHTSA needs to force Ford to recall these parts and replace them at their cost since it is a known issue!

Jan 17, 2024

steering wheel gets hard to turn anywhere. a light turns on when this happens but, I couldn't read it as I was trying to get safely out of the road. it has happened to me a couple of times. sometime it happens as I turn the car on once I put the reverse gear on it gets hard I'm able to notice this before I move so I turn the car off and when I turn it back on it fixes itself. but, last few times its happened while driving once in the highway. I was told this could be triggering my check engine light on, which now is always on, according to the shop where it was taken for a check up it is something related to a misfire of the fifth cylinder. they think it is more related to a factory defect.

Feb 17, 2022

2011 FORD EXPLORER EXHAUST LEAK EVERYTIME I GO 60 OR 70 MILE PERHOUR EXHAUST SMELL INSIDE THE CAR

Oct 17, 2017

STRUCTURE,UNKNOWN OR OTHER

3 complaints

Passenger side windshield trim came off while traveling on freeway at 85 mph hit the windshield. Then about hit the car behind us and about hit a car next to us. The car is available for inspection.

Mar 03, 2023

I HAVE LEAKS THROUGH THE SEAT BELTS ON MY THIRD ROW. MY CAR HAS A MILDEW ODOR FROM THESE SO IT HAS BEEN HAPPENING FOR A WHILE. I HAD CARMAX FIX A LEAK THAT I NOTICED IN 2016 BUT NOW 2 YEATS LATER IT IS REALLY BAD. I LOOKED UP ONLINE POSSINLE FIXES AND FOU D HUNDREDS OF OWNERS WITH THE SAME ISSUE AND NO FIX. FORD IS VERY DIFFICULT TO DEAL WITH FOR THE REPAIR. PLEAS LOOK INTO THIS FAULTY ISSUE AND REQUIRE A WELDING FIX ON THE SEEMS BY FORD. SEEMS ALL INFORMATION I HAVE FOUND WITH THE ISSUE IS WITH THE NEW EXPLORER BODY STARTING WITH MY 2011 YEAR. LEAK OCCURS QHEN IT RAINED OR WHEN CAR IS WASHED. IT IS SO MUCH WATER THAT WE CURRENTLY CAN NOT USE THE THIRD ROW SEATONG AS A SEAT. IT IS CONSTANTLY WET.

Dec 09, 2018

REGARDS FROM THE FIRST YEAR I PURCHASED I HAVE ENTERED THE EXHAUST AREA OF THE CABIN. FROM THE FIRST YEAR, SERVICE, PEOPLE WHO ATTENDED ME IN THE FORD DEALER, TOLD ME I COULD NOT FIND A CAUSE OR THAT WAS PART OF THE DESIGN OF THE UNIT. I GOT TO TAKE IT TO 2 DIFFERENT DEALERS WHENEVER I'M DRIVING AND PRESENTED ME HAVING TO CLIMB DOWN OR UP A HILL, IT IS WHERE THE PROBLEM ARISES. I MAY HAPPEN IN THE EXPRESS OR NORMAL ROADS. THE ONE LAST VISIT FOR A RECALL, RETURNED TO DISCUSS THE PROBLEM AND NOW TELLS ME IT COSTS ME $ 600 FOR THE REPAIR MEMO I GET HOW TO WORK WITH THE PROBLEM. I HAVE TROUBLE BECAUSE THEY SPENT 36,000 MILES. MY COMMENT IS THAT FROM THE FIRST YEAR'VE BEEN REPORTING THE PROBLEM AND DID NOT HAVE ANY KIND OF SOLUTION. THE SMELL IS NOW VERY OFTEN AND TRULY BOTHERS TO GUIDE AND MUST REPRESENT A HEALTH PROBLEM.

Jul 06, 2016

VISIBILITY,STRUCTURE

3 complaints

The contact owns a 2011 Ford Explorer. The contact stated while driving 70 MPH, the front windshield trim detached and flew off the vehicle. The dealer was contacted and made aware of the failure. The vehicle was not repaired. The manufacturer was contacted, and a case was filed. The failure mileage was 150,000.

Feb 24, 2023

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE DRIVING IN THE RAIN WITH THE SUN ROOF IN THE CLOSED POSITION, WATER LEAKED FROM THE SUN ROOF INTO THE CABIN OF THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. COURT ST. FORD (558 WILLIAM LATHAM DR, BOURBONNAIS, IL) WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 55,000. *TR*JB

Jul 05, 2019

AS I AM OUTSIDE TALKING TO A NEIGHBOR I HEAR A WEIRD SOUND, THEN I SEE PIECES OF DEBRIS ON THE GROUND NEAR THE REAR OF MY 2011 EXPLORER, AS I GET CLOSER I SEE PIECES OF SHATTERED GLASS JUST CRUMBLING BEFORE MY EYES AND FALLING ONTO THE GROUND. AS I LOOK UP MY REAR WINDOW LIFTGATE GLASS IS JUST SHATTERED. I CANT BELIEVE MY EYES BECAUSE I KNOW NOBODY OR NO OBJECT HIT THE GLASS. THIS HAS TO BE A FORD DEFECT IN THE GLASS AND HAS TO BE RECOGNIZED BY THEM. HOWEVER THEY ARE DENYING ME THE RIGHT TO BE COVERED UNDER MY EXTENDED WARRANTY I HAD PURCHASED. THE EXPLORER BARELY HAS 11,000 MILES ON IT. AND I AM JUST SICKENED OF FORD FOR NOT TAKEN RESPONSIBILITY. *TR

Jun 11, 2013

STEERING,ENGINE

3 complaints

The electric power steering continuesly Fails. The chain driver water pump failed while driving almost causing an accident with me and my son.

Jul 20, 2022

WAS DRIVING THE CAR AND AS SOON AS WE PULL IN THE PARKING LOT THE ENGINE LIGHT CAME ON AND THE CAR WON'T MOVE. IT WAS TOWED TO FORD MECHANIC AND THEY SAID THE WATER PUMP WAS FAULT WHICH MADE THE COOLANT TO ENTER THE ENGINE HENCE MESSING UP THE ENGINE AND I NEEDED TO REPLACE THE ENGINE. IT COST ME ARMS AND LEGS TO FIX THE ENGINE. FORD NEED TO RECALL WATER PUMP FAILURE WHICH IS LEADING TO COSTLY FIXING OF THE ENGINE. THE ROOF WAS ALSO LEAKING AND THE WATER WAS DRIPPING THROUGH BACK SEAT BELT. TODAY I WAS PULLING OFF THE PARKING THE POWER STEERING FAULT LIGHT CAME ON , AND IT WAS HARD TO TURN THE STEERING . THIS CAR HAS A LOT IF PRBLEMS .

Jan 01, 2019

I SENT MY VEHICLE IN TWO MONTHS FOR TO BE FIX AT DREW FORD DEALERSHIP. THEY ALSO CORRECTED A RECALL ON THE POWERSTEERING FAULT. NOW THE FAULT IS BACK AND THE STEERING WHEEL IS IMMOVABLE OR EXTREMELY HARD TO MOVE. THEY ALSO CLAIM THIS WILL NOT FALL UNDER THE RECALL, BECAUSE IT HAS BEEN REMEDY THE FIRST TIME. I AM VERY UPSET WITH FORD, BECAUSE THIS CAN BE A 600-2000 DOLLAR REPAIR. POWER STEERING SHOULD NOT GO THIS FAST, MY CAR IS BARELY 4 YEARS OLD. I MAY HAVE TO TRADE IT IN FOR MORE RELIABLE VEHICLE LIKE A HONDA OR TOYOTA. I WANT TO SUPPORT AMERICAN COMPANIES. THIS EXPERIENCE LEFT ME WITH A BAD TASTE IN MY MOUTH. *TR

Feb 11, 2015

STEERING,AIR BAGS

3 complaints

Airbag light stays on after have completed all the fixes as stated in the official TSB 12-5-11 05/29/12. The steering has become extremely difficult to turn at low speeds or moving for a complete stop. It is freezing up and get harder as time goes by. The recall is expired, but the symptoms are the exact same as the recall stated.

Mar 11, 2022

DRIVING 25 TO 30 MPH WHEN THE STEERING WHEEL BECAME DIFFICULT TO TURN,.CALL DEALER FORD AL PIEMONTE AND MAKE AND APPOINTMENT BUT THEY SAY IS NOT A RECALL ,THEY DIDN'T REPAIRED AS YET.( WHAT CAN I DO?) IN MELROSE PARK ILLINOIS. I TOOK THIS TRUCK FOR A RECALL IN 2017 FOR THE SAME PROBLEM AND AT THAT TIME THEY FIX IT NOT THIS TME.

Sep 16, 2019

MY CAR HAS ABOUT 95K MILES. CURRENTLY IT IS IN THE SHOP GETTING 2 THINGS DONE. A PART IS ORDERED FOR AIR BAG. I'VE HAD SEVERAL AIRBAG ISSUES NEEDED SERVICE. MY BIGGEST CONCERN IS THE POWER STEERING UNIT. I BOUGHT THE CAR NEW FROM DIBLASIO IN 2012 W/ ABOUT 7K MILES ON IT. I HAVE EXTENDED WARRANTY FROM FORD. SEPT 2016 THE ORIGINAL POWER STEERING UNIT FAILED AND WAS REPLACED. 14 MONTHS LATER THE REPLACEMENT HAS NOW FAILED AND IS BEING REPLACED! THE WARNING LIGHT CAME ON WHILE MY WIFE WAS DRIVING ON THE HIGHWAY. THANK GOD!!!!! THE POWER ASSIST DID NOT FAIL OR SHE COULD HAVE BEEN KILLED. WHEN I STARTED THE CAR THE NEXT TIME THERE WAS NO POWER STEERING. I HAD THE CAR TOWED TO DEALER. I NO LONGER TRUST THIS CAR. THE PS UNIT IS A CRITICAL PART OF THE VEHICLE. I HAVE NEVER OWNED A CAR THAT HAD A SIMILAR PROBLEM ONCE, YET TWICE. WITH THE SECOND TIME TAKING ONLY 14 MONTHS TO FAIL. I CALL FORD CORPORATE AND TOLD THEM ABOUT THE SITUATION AND THAT I NO LONGER TRUST THE CAR. LOOKING ONLINE, I SEE ARTICLES ABOUT A PS UNIT RECALL IN THE 2014S. I DON'T RECALL EVER RECEIVING A NOTICE ABOUT MY VEHICLE AND ONLY BROUGHT IT IN WHEN IT STARTED ACTING ODD IN 2016. FORD ASKED ME WHAT I WANTED THEM TO DO. AT THIS POINT I SAID I NO LONGER WANT THE CAR AND DO NOT WANT TO SELL IT TO SOMEONE WITH WHAT I KNOW AND FEAR. I THOUGHT FORD SHOULD BUY IT BACK FROM ME AT A REASONABLE PRICE AND I WILL GET A DIFFERENT VEHICLE. I WAS PUT ON HOLD FOR SHOW AND THE PERSON CAME BACK AND SAID THEY WERE SORRY THERE IS NOTHING THEY CAN DO AND THAT ANY TIME THERE IS A PROBLEM I SHOULD BRING IT TO THE DEALER. I AM DISGUSTED WITH FORD AND I DON'T KNOW WHAT MY OPTIONS ARE. I NEED HELP PLEASE. I FEAR ANYONE DRIVING THIS CAR ONCE I GET IT BACK TOMORROW.

Nov 16, 2017

STEERING,ELECTRICAL SYSTEM,ENGINE

3 complaints

DRIVING AT 35+ ENTERING ON RAMP MPH THE CAR LOST ALL POWER AND JUST STOPPED. THE ENGINE SHUT OFF. NO WARNING LIGHTS OR ALARMS WENT OFF BEFOREHAND. ONCE THE CAR STOPPED, THE ENGINE LIGHT CAME ON, THE LOW PRESSURE LAMP TOO AND AN ALARM SOUNDED. I CALLED A TOW TRUCK AND HAD IT TOWED TO (TOLD ME MY ENGINE WAS MILKY DESTOYED)TWO DEALEARS THEN TO FORD. THEY CALLED THIS MORNING AND SAID THE WATER PUMP WENT OUT CAUSING CATASTROPHIC DAMAGE TO THE ENGINE. THE ENGINE HAS TO BE REPLACED. THEY QUOTED $8,000.00. HAD TO GET A $10,000 LOAN. [TO REPLACE STEERING AND ENGINE] THIS IS THE FIRST ONE (IT SEEMS TO BE HEADED IN THE SAME DIRECTION BUT ONLY SOONER) *PLEASE HELP ME I CAN'T AFFORD THIS AGAIN**WHILE DRIVING ON THE HIGHWAY, MY POWER STEERING WENT OUT WITHOUT WARNING. I LOST ALL POWER STEERING AND THEN THE POWER STEERING ALARM CAME ON. TOOK IT TO FORD AND HAD THE POWER STEERING REPLACED AT A COST OF $1800.00. THEN, LESS THEN 2 WEEKS LATER WHILE DRIVING AT 40 MPH, THE POWER STEERING WENT OUT AGAIN. AND AGAIN, NO WARNING LIGHTS UNTIL THE POWER STEERING WEN OUT. FORD SAID IT WAS BECAUSE MY TIRES HAD LOW TREAD AND I NEEDED TO REPLACE MY FRONT TIRES, WHICH WE HAD THEM DO. 8 MONTHS AGO, THE TRANSFER CASE WENT OUT AND HAD TO BE REPLACED ALSO WHEN PLACED IN PARK VEHICLE SHUT OFF COMPLETELY SHOWING A LOW PRESSURE OIL LAMP. HAPPENED IN MY FIRST ENGINE NOW IT'S HAPPENING IN THIS NEW ONE AND ITS NOT 2YRS OLD YET JUST GOT THE NEW ENGINE MAY/ JUNE OF 2019. THE FIRST ENGINE WASN'T 10 YEARS OLD . THE FIRST ENGINE ALL THIS HAPPENED APPROXIMATELY BETWEEN 2016 AND 2019 ONGOING UNTIL 2019 I GUESS THE WATER PUMP GAVE UP.O1 O1 2020 FOR THE SECOND ENGINE ON THE SAME COURSE AS THE FIRST

Mar 31, 2021

I HAVE HAD THIS TRUCK FOR RUFFLY 3YRS. WHEN I FIRST BOUGHT THE CAR SOMETHING WAS WRONG WITH IT IMMEDIATELY.... I WAS DRIVING TO THE MAIL BOX AFTER GETTING HOME FROM ABOUT A 30MIN TRIP. THE WHOLE CAR CUT OFF LIGHTS WERE DIM IN THE CAR, STEERING HAD LOCKED VERY HARD TO TURN... AUTOMAX IN KILLEEN TOOK THE CAR IN FOR SERVICE. HAD THE NEW PURCHASED TRUCK FOR A MONTH AND 2 DAYS. THEIR SERVICE TEAM TOLD ME IT WAS THE BATTERY. I FELT OTHER WISE AND NO LONGER WANTED THE CAR. BUT OF COURSE BY THIS TIME ALL PAPERWORK HAD WENT THROUGH TO THE BANK......DROVE THE TRUCK FINE FOR ABOUT 8MONTHS, THEN BROKE DOWN THE SAME WAY AS THE VERY FIRST TIME BUT ON A BRIDGE THIS TIME...... THIS TIME AROUND I WAS TOLD IT WAS THE ENGINE, GOT A SECOND OPINION, SAID PERSON SAID WATER PUMP. I FIXED THE WATER PUMP. NOW GUESS WHAT??? ITS ACTUALLY THE ENGINE.... I AM BLOWN AWAY BY HOW MANY PROBLEMS I HAVE HAD WITH THIS FORD EXPLORER..... I THOUGHT I WAS MAKING A GREAT PURCHASE GOING WITH A FORD. THIS TRUCK SAT IN THE DRIVEWAY FOR A YEAR WHILE IN NURSING SCHOOL..... I AM LOST AND AT MY WITS END..... WHEN I LOOK FOR RECALLS ALL I AM SEEING IS SUSPENSION ISSUES OR TOWING.... WHEN I TALK TO MECHANICS THEY SAY THESE MODELS ARE KNOW FOR BAD ENGINES, THUS IS ANOTHER REASON WHY THE 2011 FORD EXPLORER ENGINES ARE MORE EXPENSIVE..... I AM LOOKING FOR HELP. HAS ANYONE ELSE HAD THESE SAME ISSUES. I OWE 14000 STILL ON THIS TRUCK AND HOW COULD IT NEED A NEW ENGINE ALREADY?

Oct 11, 2019

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE DRIVING AT ANY SPEED, THE POWER STEERING AND COMPUTER FAILED. IN ADDITION, THE ENGINE, ABS, TRACTION CONTROL, AIR BAG, AND SECURITY SENSORS ILLUMINATED. THE DEALER ADVISED THE CONTACT TO RESET THE MASTER CONTROLS. THE VEHICLE ALSO EXHIBITED COMPUTER FAILURE. THE FIRMWARE WAS UPDATED MULTIPLE TIMES, HOWEVER THE FAILURE RECURRED MONTHS LATER AND INCLUDED VARIOUS ELECTRICAL SHORTS. WHILE DRIVING AT AN UNKNOWN SPEED, THE POWER STEERING FAILED. THE VEHICLE WAS TOWED TO THE AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. THE CONTACT WAITED FOR MONTHS TO DETERMINE IF THE DEALER WAS ABLE TO PROVIDE A REMEDY TO THE FIRMWARE FAILURE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 14V286000 (STEERING) AND 14E001000 (STEERING). THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.

Sep 11, 2014

VEHICLE SPEED CONTROL,ENGINE

3 complaints

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE DRIVING 40 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED; HOWEVER, THE VEHICLE WAS SLUGGISH AND LOST POWER. ALSO, THE BRAKES AND STEERING BECAME INOPERABLE AND THE OIL PRESSURE AND CHECK ENGINE WARNING INDICATORS WERE ILLUMINATED. THE CONTACT ALSO HEARD AN ABNORMAL CRANKING NOISE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO STATED THAT THE WATER PUMP FAILED AND OIL WAS IN THE COOLANT. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 131,000.

Nov 22, 2019

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING WHILE THE CRUISE CONTROL WAS SET AT 58 MPH. THE CONTACT WAS ABLE TO COAST THE VEHICLE ONTO THE ROAD SHOULDER. ONCE THE VEHICLE WAS RESTARTED, IT RESUMED NORMAL OPERATION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 83,000.

Nov 30, 2015

AFTER A RAPID ACCELERATION IN ORDER TO GET TO TOLL SPEEDS (65MPH) THE VEHICLE STARTED TO PRODUCE A BURNT SMELL. THOUGHT IT COULD BE NEW VEHICLE STUFF BUT RIGHT KNOW ITS 30,000 MILES AND EVERY TIME I GO OVER 4000 RPM ON A RAPID ACCELERATION IT GIVES ME THE ODOR, PLUS THE VEHICLE LOSSES POWER ON THE HILLS. DISAPPOINTING WHEN YOU PAY OVER 40,000 FOR A NEW LUXURY SUV. *TR

Oct 30, 2013

ELECTRICAL SYSTEM,UNKNOWN OR OTHER

3 complaints

STARTED THE FORD AND THE BACKUP CAMERA WAS NOT FUNCTIONING. ALSO NOTICED THE 'SYNC' SCREEN WAS BLANK, CLIMATE CONTROLS WERE NOT VISIBLE (FUNCTIONING) AS WELL AS THE RADIO SYSTEM WAS NOT FUNCTIONING. WENT OUT AND STARTED THE SUV IN MY DRIVEWAY, EVERYTHING WAS CORRECT WHEN I RETURNED HOME THE NIGHT BEFORE.

Oct 17, 2019

APIM NOT WORKING IN TOO MANY CARS I SEEN INTERNET

Oct 07, 2017

WHILE IDLING AND WHILE GETTING CAR UP TO SPEED THE AC COOLING MAKES A WEAK SOUND AND DOES NOT PRODUCE COOL AIR. WHILE IDLING THE CAR OVERHEATS WHEN THE AC IS ON AND BLOWS HOT AIR. DUE TO THE EFFECT THIS IS A CAR WITH LESS THAN 60,000 MILES ON IT THE AC SHOULD STILL BE IN OPERATIONAL CONDITION GIVEN IT'S ONLY USED 2-3 MONTHS A YEAR SINCE OWNERSHIP. CAR WILL ALSO OVERHEAT WHILE IT'S BLOWING HEAT DURING WINTER MONTHS. ENGINE COOLANT IS AT OPTIMUM LEVELS AND CAR WILL SMOKE WHILE EXHAUST IS ON. THIS NEEDS TO BE ADDRESSED AND AN INVESTIGATION SHOULD BE DONE AS READING NUMBERS REVIEWS ON-LINE THIS IS AN ONGOING ISSUE WITH ALL FORD MODEL VEHICLES, AVERAGE COSTS TO REPAIR ARE OVER $2,000 TO REPLACE WHAT SHOULD BE A NEW AC SYSTEM, WE SHOULD NOT BE HAVING TO REPLACE THE ENTIRE SYSTEM DUE TO KNOWN FAILURE BY FORD.

Jul 07, 2015

STEERING,ELECTRICAL SYSTEM,ELECTRONIC STABILITY CONTROL (ESC)

3 complaints

THE BATTERY CHARGING SYSTEM COMES ON WHILE DRIVE AT NORMAL SPEED AND THE STEERING BECOMES VERY HARD AND THEN EVERYTHING SHUTS DOWN AND IF YOU ARE LUCKY YOU MIGHT MAKE IT OFF THE SIDE OF THE ROAD. THIS IS VERY SCARY AS I LIVE IN A RURAL AROUND WHERE YOU CAN'T ALWAYS GET OVER IN AN APPROPRIATE AREA. IN THE PAST I COULD LET IT SET FOR A MINUTE AND RESTART IT AND WOULD BE FINE. RECENTLY HAD TO HAVE IT JUMP STARTED FOR IT TO RUN AGAIN AND THEN SEEMS FINE. JUST LAST NIGHT/THIS MORNING IT WAS SO BAD THAT WE HAD TO LET IT SIT FOR SEVERAL HOURS BEFORE WE COULD GET IT TO JUMP START IT AGAIN. I HAVE SAW THAT OTHERS HAVE HAD SIMILAR COMPLAINTS. WHEN I SEARCHED MY VIN NUMBER IT SAYS THERE IS NO RECALLS BUT WHEN I WAS SEARCHING FOR RECALLS IT MENTIONS THE POWER STEERING AS A RECALL. THE RECALL WAS PRIOR TO ME PURCHASING THIS UNIT. I AM FRUSTRATED AND THIS IS A GREAT SAFETY RECALL THAT FORD SHOULD FIX ON ALL VEHICLES. THE DATE ENTERING AS EVENT HAPPENED WAS THE LAST EVENT BUT IT STARTED BACK IN MAY OF 2016. *TR

Jan 17, 2017

WHILE DRIVING MY VEHICLE IT LOST POWER STEERING ASSIST SYSTEM SHOWED "POWER STEERING ASSIST FAILURE" AS WELL AS "SERVICE TRACTION CONTROL". THIS WAS THE SCARIEST FEELING I HAVE EVER HAD. THIS HAS HAPPEN TO MY HUSBAND SEVERAL TIMES.. I IMMEDIATELY CALLED MY LOCAL FORD DEALERSHIP SPOKE WITH SERVICE ADVISOR. I WAS TOLD TO TURN MY VEHICLE OFF AND RESTART IT. I ADVISED MY SERVICE ADVISOR THAT I HAD TAKEN MY VEHICLE IN FOR SERVICE ON APRIL 30, 2012 (40197 MILES) AND I MENTION THIS SAME PROBLEM FOR REPAIR. WHAT IS IT GOING TO TAKE FOR FORD TO REALIZE THAT THIS IS A SERIOUS, SERIOUS PROBLEM. I AM AFRAID FOR MY FAMILY TO BE IN THIS CAR, WE TRAVEL ALOT AND I AM REFUSING TO DRIVE IT. I WAS AFRAID OF PURCHASING AN AMERICAN CAR BUT LOVED THE NEW FORD EXPLORER LOOK AND BODY. HOWEVER, I DON'T THINK I'LL EVER PURCHASE ANOTHER FORD VEHICLE AND I WILL TRADE THIS CAR ASAP........ *TR

Jun 11, 2012

WHILE IN OPERATION VEHICLE LOST POWER STEERING ASSIST. STEERING BECAME EXTREMELY DIFFICULT. WARNING MESSAGE "POWER STEERING ASSIST FAILURE" FOLLOWED BY "SERVICE TRACTION CONTROL " LIGHT ARE DISPLAYED. SHUTTING OFF VEHICLE AND RESTART TEMPORARILY CLEARED THE FAILURE. FAILED MORE THAN ONCE. *JS

Jun 07, 2012

POWER TRAIN,ELECTRICAL SYSTEM

3 complaints

FAULTY ELECTRICAL SWITCH WITHIN THE GEAR SHIFTER KNOB PERIODICALLY INDICATES THAT CAR IS NOT IN "PARK" WHEN THE CAR IS ACTUALLY IN PARK. THIS IS WORRISOME SINCE YOU ARE ALWAYS AFRAID YOUR CAR WILL ROLL AWAY. THIS PROBLEM OCCURS PERIODICALLY FOR ME AND IS REMEDIED TEMPORARILY BY FRANTICALLY "CLICKING" THE GEAR SHIFTER SWITCH UNTIL THE MESSAGE GOES AWAY. THIS PROBLEM SEEMS TO BE A PROBLEM THAT IS NOT UNIQUE TO ME. THERE ARE SEVERAL POSTS ONLINE ABOUT THE EXACT SAME ISSUE.

Oct 13, 2015

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE ACCELERATING FROM A TRAFFIC LIGHT, THE VEHICLE STARTED TO VIBRATE UNCONTROLLABLY. THE CONTACT STATED THAT THE FAILURE ONLY OCCURRED WHEN DRIVING FROM A COMPLETE STOP OR WHEN DECREASING IN SPEED. ALSO, WHILE DRIVING 15 MPH, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE FAILURE ONLY OCCURRED ONCE. THE CONTACT ALSO STATED THAT THE INTERIOR LIGHTING ON THE INSTRUMENT PANEL WOULD DIM OCCASIONALLY WHILE DRIVING. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 36,800.

Sep 22, 2015

WHILE DRIVING TO WORK, MY VEHICLE EXPERIENCE AN ISSUE WITH THROTTLE RESPONSE. A WRENCH WARNING LIGHT APPEARED AND THE CHECK ENGINE LIGHT CAME ON. AT THAT POINT, THE VEHICLE BEGAN SHUDDERING AND THE INTERNAL SYSTEMS SLOWED THE VEHICLE TO APPROXIMATELY 5MPH. AFTER STOPPING ON THE SHOULDER OF THE INTERSTATE, I SHUT THE CAR OFF, PULLED THE KEY, REINSERTED THE KEY AND RESTARTED THE VEHICLE. IT STARTED UP NORMALLY, BUT IMMEDIATELY EXHIBITED THE SAME SYMPTOMS. I CHECKED THE OWNER'S MANUAL AND FOUND THAT THE WRENCH WARNING LIGHT INDICATES A "POWERTRAIN FAULT". I CONTACTED FORD ROADSIDE ASSISTANCE AND GOT THE VEHICLE TOWED TO THE NEAREST DEALERSHIP, THINKING THAT A WARNING LIGHT INDICATING A "POWERTRAIN FAULT" WOULD BE COVERED UNDER MY POWERTRAIN WARRANTY. THE DEALERSHIP DIAGNOSED THE PROBLEM AS AN ISSUE WITH THE THROTTLE BODY OF THE VEHICLE, THAT THE THROTTLE BODY IS NOT COVERED UNDER THE POWERTRAIN WARRANTY, AND CHARGED ME OVER $700 TO FIX THE PROBLEM. *TR

Sep 16, 2014

EQUIPMENT

3 complaints

WHEN ACCELERATING THE VEHICLE QUICKLY WITH THE AIR CONDITIONER ON (DOES NOT MATTER IF IT'S ON FRESH AIR INTAKE OR RECIRCULATION), THERE IS A DEFINITE BURNT SMELL THE CABIN OF THE VEHICLE. THE PROBLEM CAN BE DUPLICATED AT ANY SPEED, FROM A DEAD STOP OR ACCELERATING DURING A PASSING MANEUVER. THE VEHICLE WAS TAKEN TO THE LOCAL DEALERSHIP THREE TIME AND TWO TECHNICAL BULLETINS WERE ADDRESSED UPON COMPLETION OF THE FACTORY WARRANTED TECHNICAL BULLETINS, THE ODOR REMAINED. BURNT SMELL. *JS

Sep 24, 2013

2011 FORD EXPLORER. CONSUMER WRITES IN REGARDS TO ISSUES WITH A "MY FORD TOUCH" VOICE ACTIVATED SYSTEM. *TGW THE CONSUMER STATED THE "MY FORD TOUCH" IS A VOICE OR TOUCH SCREEN ACTIVATED SYSTEM THAT CONTROLLED ENTERTAINMENT, CLIMATE, NAVIGATION AND HANDS FREE CELL PHONE FUNCTIONS. WHEN THE SYSTEM STOPPED WORKING, THERE WAS NO CONTROL OVER ANY OF THE AFOREMENTIONED DEVICES. THE CONSUMER HAD TO TAKE THE VEHICLE TO THE DEALER THREE TIMES, BECAUSE OF THE MALFUNCTIONING SYSTEM. A TYPICAL PROBLEM WAS THE SYSTEM LOCKING UP, THE SCREEN WOULD FREEZE AND THERE WAS NO CONTROL OVER THE HEATER/AIR CONDITIONER OR RADIO VOLUME. USUALLY AFTER 10-12 MINUTES THE SCREEN WOULD GO BLANK AND A MESSAGE APPEARED THAT READ PERFORMING SCHEDULE MAINTENANCE. WHEN THE SYSTEM WAS FINALLY RESTORED, EVERYTHING WORKED AGAIN. SOMETIMES WHEN USING THE NAVIGATION TO FIND AN ADDRESS, THE CAR ICON WOULD WANDER OFF THE PRESCRIBED ROUTE EVEN THOUGH THE CONSUMER WAS DRIVING THE PRESCRIBED ROUTE. WHEN THAT HAPPENED, THE SCREEN WOULD OFTEN DISPLAY A LARGE YELLOW QUESTION MARK. THE FIRST TIME THE CONSUMER VISITED THE DEALER, THEY FLASHED THE MEMORY. IT HELPED, BUT IT STILL FAILED, AT TIMES. THE SECOND TIME, HE RETURNED TO THE DEALER, THEY INSTALLED AN UPDATED PROGRAM FROM FORD THAT WAS SUPPOSED TO CORRECT THE PROBLEMS. BUT, AS TIME WENT ON, THE NEW PROGRAM STARTED TO FAIL IN A SIMILAR WAY AS THE OLD PROGRAM. THE LAST TIME, THE CONSUMER VISITED THE DEALER, THEY DID A MASTER RESET BY DISCONNECTING THE BATTERY, THEREBY REMOVING ALL POWER FROM THE SYSTEM AND REBOOTING IT WHEN THE BATTERY WAS RECONNECTED. THE DEALER INFORMED THE CONSUMER, HE COULD ALSO PULL FUSE 29 AND PUT IT BACK IN AGAIN. HOWEVER, THE CONSUMER STATED HE WAS NOT ABLE TO REACH THE FUSE, AS IT WAS TUCKED WAY UP UNDER THE DASHBOARD, BUT EVEN IF HE COULD REACH IT, IT WOULDN'T FIX THE DEFECTIVE SOFTWARE PROVIDED BY FORD AND MICROSOFT. DISCONNECTING THE BATTERY DIDN'T FIX THE PROBLEM, IT ONLY REBOOTED THE COMPUTER AND EVENTUALLY, THE PROBLEM WOULD RETURN. *JB

Dec 06, 2012

WE HAVE PURCHASED A 2011 EXPLORER, WITH THE BLUETOOTH ACTIVATED, THE PERSON DRIVING CANNOT BE HEARD BECAUSE OF BACKGROUND NOISE. FROM MY INVESTIGATION, I FOUND THAT THE ROOF AREA ABOVE THE WINDSHIELD SEEMS TO NOT HAVE ANY INSULATION, THE WIND NOISE IS BEING PICKED UP BY THE SPEAKER ABOVE THE DRIVERS HEAD. THIS IS NOT THE ONLY PROBLEM, WHEN IT IS RAINING THE NOISE FROM THE RAIN SOUNDS LIKE A TIN ROOF OF AN OLD HOUSE. I REPORTED THIS TO THE DEALERSHIP AND THEY SAID THAT THERE IS NOT ANYTHING THEY CAN DO WITHOUT FORD HAVING MORE COMPLAINTS. *TR

Aug 08, 2011

SERVICE BRAKES, HYDRAULIC

3 complaints

I PULLED INTO A PARKING STALL AND APPLIED THE BRAKES. THEY FAILED AND I ONLY STOPPED AFTER HITTING THE GLASS DOORS OF A CLOSED BUSINESS. I DID NOT HIT THE GAS PEDAL AND WAS STOPPED DUE TO THE BUSINESS' GLASS FRONT DOORS. I HAVE BEEN DRIVING FOR OVER 37 YEARS AND NEVER ENCOUNTERED A PROBLEM LIKE THIS. NO ONE WAS HURT THANKFULLY, BUT THE PROBLEM IS STILL UNRESOLVED. INTERNET SEARCH REVEALED OTHER EXPLORERS FROM OTHER YEARS (2005, 2007 & 2009) ALSO HAD SIMILAR BRAKE FAILURES AND FORD COULD NOT FIND A PROBLEM WITH THE BRAKE SYSTEMS ON THOSE CARS, BUT SOMETHING IS DEFINITELY NOT RIGHT. SEE WWW.EDMUNDS.COM & TYPE IN "EXPLORER BRAKE FAILURE". CHECK OUT POSTS #12, 37, 38, 39, 40 AND 42. FORD DEALERSHIP FOUND NO PROBLEMS WITH THE BRAKES, BUT THEY CLEARLY FAILED. I DON'T WANT SOME INNOCENT PERSON HURT DUE TO BRAKE FAILURE DOWN THE ROAD. ANY HELP YOU CAN PROVIDE WOULD BE GREATLY APPRECIATED.

Oct 22, 2011

Crash: 1

THE ABS SYSTEM IS COMMANDING INPUTS TO THE BRAKES WITHOUT DRIVER INPUT AT VARIOUS SPEEDS AND CAUSING STEERING WHEEL TORQUE. THIS HAPPENS REGARDLESS OF ROAD CONDITIONS. THE COMPUTER HAS BEEN REPLACED ONCE AND THE CAR IS STILL UNSAFE TO DRIVE. *TR

Sep 06, 2011

MY NEW FORD EXPLORER IN ENGAGING THE BRAKES WITHOUT DRIVER INPUT. IT APPLIES ONE BRAKE AT A TIME AT ALL SPEEDS. IT TORQUES THE STEERING WHEEL TO THE POINT OF LOSING CONTROL. *TR

Aug 08, 2011

STEERING,WHEELS

2 complaints

Power steering assist fault, and power steering EPS system failed while driving! Was replaced by Ford in 2015 and has already locked up while driving! Tire pressure sensor constantly stays on even after replacement.

Feb 26, 2025

My car show me warning Power steering assist fail Now my car not drive because cant turn right or left is too hard Engine and transmission is ok Power steering recall was in past Now I try get help from dealer they say not recall for steering is weird Epas 15N01 recall Still original parts on my car Please what I need to do Thanks

Jan 24, 2024

STEERING,POWER TRAIN,ELECTRICAL SYSTEM

2 complaints

As I was driving, a “service Power steering” warning came on along with another warning about my power assist being lost. I have taken my car to see a mechanic a total of 4 times for this same issue and need answers or reimbursement.

Nov 28, 2024

THE STEERING FAILED WHILE DRIVING THE VEHICLE ON 4 OCCASIONS IN MY BRAND NEW XLT. THE FIRST THREE TIMES IT HAPPENED I RETURNED IT TO THE DEALER TO CHECK IT OUT AND FIX THE PROBLEM. EACH TIME (THREE TOTAL) THE FORD DEALER SERVICE DEPARTMENT RETURNED IT TO ME AND TOLD ME IT WAS FIXED. WHILE DRIVING THE VEHICLE IN NORMAL DRIVING CONDITIONS THE STEERING WOULD SUDDENLY STOP WORKING, WARNING CHIMES AND LIGHTS ON THE DASHBOARD "SERVICE ADVANCE TRAC", "POWER STEERING ASSIST FAULT", "TERRAIN MANAGEMENT SYSTEM FAULT" AND TRACTION CONTROL FAILURE AND TRACTION CONTROL OFF LIGHTS GLOWING WHILE IN MOTION. ALMOST CRASHED THE VEHICLE EACH TIME IT HAPPENED. THE VEHICLE WOULD ALSO SLOW DOWN EVEN THOUGH MY GAS PEDAL POSITION NEVER CHANGED. WHEN IT HAPPENED THE 4TH TIME, I ALMOST WAS IN A FATAL ACCIDENT WITH A TRACTOR TRAILER AND REALIZED FORD MOTOR CORPORATION IS NOT INTERESTED IN FIXING THIS PROBLEM OR ADDRESSING THIS LIFE SAFETY ISSUE ALL LATE MODEL EXPLORER OWNERS ARE FACED WITH. FORD CLAIMED THEY KNOW NOTHING BUT SAME ISSUE ALL OVER INTERNET. THEY CLAIMED THE FIX WAS THEY REPLACED AN ANGLE SENSOR IN THE STEERING COLUMN, ANOTHER TIME IT WAS THE COMPUTER NEEDED TO BE REFRESHED AND ANOTHER SAID THERE WAS NO RECORD IN THE ONBOARD COMPUTER, NOTHING TO FIX. AS I AM NOT AN EXPERT, IT SEEMS LIKE THE COMPUTER IS FAULTY BECAUSE THE SYNC AND NAVIGATION NEVER WORKED PROPERLY. WAS THERE A CRASH? WAS THERE AN INJURY OR FATALITY? I BELIEVE IF IT HAS NOT HAPPENED YET, IT WILL. THE HEAD OF CUSTOMER SERVICE OPERATIONS MANAGER TOLD ME I HAD TWO OPTIONS "CALL THE BETTER BUSINESS BUREAU", OR "CALL AN ATTORNEY". I WILL BE DOING BOTH. I WILL NEVER BUY ANOTHER FORD BECAUSE OF THEIR INABILITY AND UNWILLINGNESS TO HELP ME IN THIS. FORD CUSTOMER SERVICE FROM THE DEALER LEVEL THROUGH THE TOLL FREE CORPORATE HOTLINE WAS ABSOLUTELY HORRIFYING. SEARCH ONLINE FOR OTHERS UNREPORTED HERE. *TR

Aug 06, 2012

STEERING,FORWARD COLLISION AVOIDANCE

2 complaints

Power Steering just went out with no warning. Plus 3 other failures Service advance Trac Power Steering fault and Terrain Management Fault. All these occurred at the same time.

Aug 01, 2024

Electric power steering failed without any warning. Ford HAD a voluntary recall, but as a second owner I did not get any notification. As vehicles are supposed to exceed 100k miles this is disturbing (like iPhone battery fiasco). Electric steering is nearly impossible to drive and being thIs is a KNOWN problem with this vehicle and the fact it is the #1 vehicle currently utilized by Law Enforcement I find it odd there is not a mandatory safety recall for this issue. Thank you, [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Sep 14, 2022

FUEL SYSTEM, GASOLINE

2 complaints

The contact owns a 2011 Ford Explorer. The contact stated that while driving at an undisclosed speed, the contact detected an abnormal fuel odor. The vehicle was taken to an independent mechanic, who diagnosed that there was a vapor leak coming from the top of the fuel tank. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 102,000.

Mar 23, 2023

THE CHECK ENGINE LIGHT WENT ON MY 2011 FORD EXPLORER ON 11/21/11 AND TOOK IT TO THE DEALER AT WHICH TIME I WAS TOLD IT WAS A LEAK IN THE GAS CAP (BUT THIS CAR HAS A CAP-LESS GAS TANK) CHECK ENGINE LIGHT WENT OFF AND BACK ON WITHIN 1 WEEK, TOOK IT BACK ON 11/26/11 AND AT THAT TIME THEY SAID THEY GOT THE SAME READING WITH THE GAS CAP ISSUE AND THEY CHANGED A SOLENOID. CHECK ENGINE LIGHT WENT OFF ONLY TO GO BACK ON 3 DAYS LATER. DROPPED MY CAR OFF AT DEALER ON 12/3/11 FOR 3RD TIME AND NOW THEY TOLD ME THEY KEEP GETTING SAME ERROR CODE AND THEY SENT ISSUE TO TECH'S IN DETROIT FOR ASSISTANCE. I WILL BE DROPPING MY CAR OFF TODAY (12/7/11) AGAIN TO SEE IF THEY CAN FIX IT. CHECK ENGINE LIGHT REMAINS ON. *TR

Dec 07, 2011

STEERING,TRACTION CONTROL SYSTEM

2 complaints

The contact owns a 2011 Ford Explorer. The contact stated that the vehicle was recently repaired under an unknown steering recall. The contact stated that while driving at various speeds, the vehicle lost power steering functionality. The steering assist, traction control, and an unknown warning light were illuminated during the failure. The contact stated that the vehicle would regain power steering functionality a day or two after the failure. The failure had recurred three times within the month. The contact had contacted the dealer who diagnosed that the power steering rack needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure. The manufacturer confirmed that the vehicle was out of warranty and referred the contact to NHTSA for assistance. The approximate failure mileage was 142,000.

Mar 03, 2022

I WAS SLOWING DOWN AND GETTING INTO THE LEFT TURN LANE. THE LIGHT WAS GREEN SO I STARTED TO TURN LEFT AND THE TRACTION LIGHT SYSTEM CAME ON, BOTH LIGHTS, AND THE STEERING SYSTEM FAILURE ALERT CAME ON AND I LOST ALL POWER STEERING AND ALMOST HIT A POLE. IT WAS A NICE DAY, NO RAIN OR MOISTURE. THE PAVEMENT WAS DRY. *TR

Aug 23, 2012

ELECTRICAL SYSTEM,VISIBILITY

2 complaints

The contact owns a 2011 Ford Explorer. The contact stated that the APIM (Accessory Protocol Interface Module) had become defective which caused the front and rear defrosters to not operate as needed. The contact also stated that the APIM failure had caused the rear backup camera to not function. The contact had taken the vehicle to the dealer and was provided an estimate for the repair. The manufacturer was also notified of the failure but offered no assistance. The vehicle had yet to be repaired. The failure mileage was approximately 60,000.

Feb 02, 2022

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT THE AIR CONDITIONER/HEATING UNIT FAILED CAUSING THE WINDOWS AND THE WINDSHIELD TO BE UNABLE TO DEFROST. THE VEHICLE WAS TAKEN TO THE DEALER (AUTONATION FORD NORTH CANTON, 5900 WHIPPLE AVE NW, NORTH CANTON, OH 44720, 1-877-346-8338) WHERE IT WAS DIAGNOSED THAT 1 OF THE 4 MOTOR BLENDERS FAILED AND NEEDED REPLACEMENT. THE VEHICLE WAS REPAIRED AT A DISCOUNTED RATE BUT APPROXIMATELY ONE YEAR LATER THE FAILURE REOCCURRED WHERE ANOTHER 1 OF THE 4 MOTOR BLENDERS FAILED. THE VEHICLE WAS TAKEN BACK TO THE SAME DEALER WHERE THE SECOND MOTOR BLENDER WAS REPLACED. THE VEHICLE WAS REPAIRED AND COVERED UNDER AN EXTENDED WARRANTY PROGRAM PURCHASED BY THE CONTACT. THE VEHICLE WAS REPAIRED HOWEVER THE CONTACT WAS CONCERNED THAT THE OTHER 2 MOTOR BLENDERS IN THE VEHICLE WOULD ALSO FAIL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 29,416. *TT *JB

Oct 23, 2018

ELECTRICAL SYSTEM,AIR BAGS

2 complaints

NUMEROUS REPAIRS TO AIRBAG SYSTEM. AIRBAG LIGHT IS ON AND PREVIOUS REPAIRS INCLUDE, SEATBELT TENSIONER, SEVRERAL JUMPERS AROUND THE CONNECTION UNDERNEATH DRIVERS SEAT, AS WELL AS SOME KIND OF PROGRAMMING IN THE COMPUTER SYSTEM. IVE OWNED THE VEHICLE SINCE IT WAS BRAND NEW AND IT HAS BEEN IN DEALER AT LEAST 6 TIMES FOR AIIRBAG ISSUES. PLEASE DO A FULL INSPECTION OF THE AIRBAG SYTEM INCLUDING FAULTY WIRING HARNESS!!!

Jul 24, 2019

THE "SYNC" TOUCHSCREEN STOPPED WORKING. ONCE THIS HAPPENED THE PASSENGER SIDE AIRBAG SETS TO "OFF" ALL THE TIME. THE FORD DEALER REPORTS IT REQUIRES A NEW APIN, WHICH WAS COVERED UNDER A RECALL BUT ONLY FOR 5 YEARS FROM DATE OF NEW PURCHASE.

Jul 25, 2018

ENGINE,FUEL/PROPULSION SYSTEM

2 complaints

"2011 FORD EXPLORER CARBON MONOXIDE POISONING CONCERNS RECALL" ACCIDENT OCCURRED ON MAY 14, 2019 AT HOUSTON, TEXAS I SLEPT OFF WHILE DRIVING AND RAN INTO ANOTHER VEHICLE WHO STOPPED AT A STOP LIGHT WAITING FOR THE GREEN LIGHT TO TURN ON. I WAS NOT ABLE TO STOP AT THE STOP LIGHT BECAUSE I SLEPT OFF BECAUSE OF CARBON MONOXIDE POISONING. I HAD NO REASON TO EXPERIENCE SUCH. I WAS ALSO, CONSTANTLY SMELLING FUEL COMING INTO MY 2011 FORD EXPLORER. THE CAR I RAN INTO AND MINE WERE SERIOUSLY DAMAGED. THE POLICE CAME AND WROTE A REPORT ON THE ACCIDENT. ON TWO DIFFERENT MORE OCCASIONS, SAME THINGS HAPPENED TO ME, BUT LUCKILY I DID NOT RUN INTO ANY OTHER CAR OR DAMAGE MY CAR. IT WAS AT THIS JUNCTURE THAT I STARTED TALKING WITH FRIENDS AND FAMILY MEMBERS ABOUT MY REPEATED SAD EXPERIENCE DRIVING MY 2011 FORD EXPLORER AND WAS INFORMED BY ONE OF MY FAMILY MEMBERS THAT THERE WAS A NATIONWIDE RECALL ON FORD EXPLORER BECAUSE OF CARBON MONOXIDE POISONING CONCERNS. I DIRECTLY VERIFIED AND DISCOVERED IT WAS TRUE. I THEN WASTED NOT TIME TO CALL, MAC HAIK FORD MOTOR COMPANY, HOUSTON, TEXAS AND COMPLAINED ABOUT MY EXPERIENCE DRIVING MY 2011 FORD EXPLORER AND QUESTION WHY I WAS NOT ON TIME, OFFICIALLY INFORMED ABOUT THE 2011 FORD EXPLORER CARBON MONOXIDE POISONING CONCERNS RECALL. THEY APOLOGIZED AND ASKED ME TO BRING IN MY VEHICLE TO BE FIXED FREE OF CHARGES. I TOOK MY VEHICLE TO MAC HAIK, WHERE THE FIXED ONLY THE RECALLS AND NOT THE OVER FIVE THOUSAND DOLLARS BODY AND INTERNAL DAMAGES MY VEHICLE SUSTAINED. MY QUESTION NOW IS HOW CAN I GET FORD MOTOR COMPANY TO FIX MY DAMAGED VEHICLE AND THE OTHER VEHICLE I RAN INTO BECAUSE OF THE EFFECTS OF CARBON MONOXIDE POISONING WHICH I SUFFERED WHILE DRIVING MY 2011 FORD EXPLORER, FREE OF CHARGES? *TT *TR CONSUMER STATED CAR WAS REPAIRED, FREE OF CHARGE. 'PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB

Jul 22, 2019

Crash: 1

DRIVING DOWN THE INTERSTATE AT 70MPH, WARNING COMES ON THE CONSOLE "AWD IS OFF" AND THE ENGINE IS DOWN TO IDLE SPEED (~800 RPM). PRESSING THE ACCELERATOR RESULTS IN NO SPEED INCREASE, FORCING ME TO MOVE ACROSS 4 LANES OF TRAFFIC TO THE EMERGENCY LANE WITH ONLY THE BRAKES WORKING (NO CONTROL OVER MY SPEED, OTHERWISE). PULLED OVER, STOPPED THE ENGINE, LOOKED AROUND AND COULD SEE NO EXTERNALLY VISIBLE PROBLEMS (FLUID LEAKS, ETC.). START THE CAR AND THERE ARE NO WARNINGS, SO I CONTINUE DOWN THE ROAD, BUT THIS TIME STAY IN THE RIGHT LANE AND KEEP THE SPEED TO AROUND 60. LESS THAN 1 MILE DOWN THE ROAD, THE EXACT SAME THING HAPPENS. AT THIS POINT WE CALL FORD TO GET US A TOW. THIS WAS A VERY DANGEROUS EVENT TO HAPPEN, ESPECIALLY WHEN I HAD THE EXPLORER FULL WITH MY FAMILY! TODAY THE SERVICING DEALER CALLED AND SAID IT IS A PROBLEM WITH THE THROTTLE BODY. BEING THAT THIS IS THE 2ND TIME OUR 2011 EXPLORER HAS LEFT US STRANDED ON THE SIDE OF THE ROAD, IT WAS TIME TO GO SEARCHING FOR OTHERS WITH THIS SAME THROTTLE BODY PROBLEM. TURNS OUT THERE IS A CUSTOMER SATISFACTION NOTICE ALREADY BEING DONE BY FORD FOR SEVERAL OTHER 2011 VEHICLES, BUT THE EXPLORER HAS BEEN EXCLUDED. OUR SYMPTOMS AND PART FAILURE ARE EXACTLY THE SAME AS THESE OTHER MODELS, SOME EVEN FROM THE SAME ASSEMBLY PLANT. I THINK FORD NEEDS TO EXTEND THE 13N03 PROGRAM TO INCLUDED THE EXPLORERS. THANK YOU. *JS

Jul 07, 2014

EXTERIOR LIGHTING

2 complaints

THE SAFETY HAZARD LIGHTS BUTTON DOES NOT WORK. UNABLE TO TURN HAZARD LIGHT ON. BUTTON IS COMPLAINED ABOUT IN MANY ONLINE FORMS FOR DYING OR JUST NOT WORKING.

Dec 06, 2018

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT THE ILLUMINATION OF THE HEADLIGHTS WAS EXTREMELY DIM. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED THE CONTACT THAT THEY WOULD ADJUST THE LIGHTS. THE VEHICLE WAS REPAIRED FOR THE ADJUSTMENT OF THE HEADLIGHTS. THE SAME FAILURE RECURRED SOON AFTER THE ADJUSTMENT. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 5. UPDATED 02/09/12*LJ THE CONSUMER STATED THE HEAD LIGHTS WERE DESIGNED TOO CLOSE TOGETHER. UPDATED 02/13/12

Jan 09, 2012

UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM

2 complaints

MY VEHICLE PRODUCES UNBEARABLE SMELL THAT GETS INSIDE THE CABIN WHENEVER THE RPM REACHES 3500 AND HIGHER AND IF THE VEHICLE IS IN LOW GEAR AND DRIVING UP HILL AND ALSO WHEN VEHICLE IS IDLE AND YOU RAVE UP TH ENGINE. THE SMELL THAT GETS INSIDE THE CABIN COULD MAKE ONE PASS OUT UNLESS WE ROLL DOWN THE WINDOWS COMPLETELY TO LET A LOT OF FRESH AIR INSIDE. I WENT THE DEALERSHIP WHICH I BOUGHT THE VEHICLE FROM THE FIRST MONTH AND THEY INSPECTED THE CAR AND GOT BACK TO ME THAT THIS ISSUE HAS BEEN ALREADY RESOLVED BEFORE I HAD BOUGHT THE CAR AND ITS FIXED ALREADY BUT ITS NOT I'VE DRIVING THE CAR NOW FOR ABOUT 5 MONTHS AND VERY CAUTIOUS WITH IT AS WHENEVER THE INCIDENT HAPPENS I FEEL VERY DIZZY BY THAT SMELL. SO THE ISSUE NEVER BEEN FIXED AS MY VIN NUMBER DOES NOT HAVE A RECALE WHEN I CHECKED IT ON THE NHTSA AMD IN ORDER FOR THE ISSUE TO BE FIXED BIN HAS TO BE RECALED LIKE OTHER SIMILAR EXPLORERS WITH THE SAME ISSUE. MOST OF THE OLDER MODES OF POLICE INTERCEPTORS EXPLORERS HAD RECALLS FOR SAME ISSUE. SOMEONE PLEASE ADVICE ME ON HOW I CAN GO ABLUT THIS TO GET SOME RESOLUTION.

Sep 30, 2018

WHILE DRIVING THE SUV, AN ORANGE WRENCH ERROR CAME ON THE DASH BOARD. THEN THE SUV HAD NO ACCELERATION. I WAS ABLE TO COAST TO THE SIDE OF THE ROAD, TURN OFF THE SUV AND TURN IT BACK ON. AFTER RESTARTING THE ENGINE, THE SUV HAD ACCELERATION, BUT THIS ERROR AND NO ACCELERATION KEEPS HAPPENING. I HAVE BEEN TOLD THIS IS AN ELECTRONIC THROTTLE BODY ISSUE THAT FORD IS AWARE OF, BUT DOESN'T HAVE A RECALL LISTED FOR THIS ISSUE FOR MY TRUCK.

Oct 26, 2017

AIR BAGS,SEAT BELTS,UNKNOWN OR OTHER

2 complaints

2011 FORD EXPLORER THAT I BOUGHT NEW IN 03/2011 AND THAT HAS AN ISSUE ABOUT THE AIRBAG LIGHT BEING ON AND OFF AT THE VERY FIRST MONTH OF THE CAR PURCHASE IT HAS BEEN CONSTANTLY CHECKED AND FIXED FOR FREE WITHIN THE TIME WARRANTY. THEN I HAVE TO COME AND PAY ALMOST EVERY YEAR TO FIX THE AIRBAG LIGHT.

Oct 07, 2017

VEHICLE SRS WARNING LIGHT ILLUMINATED AND EXTINGUISHED SPORADICALLY FOR SEVERAL DAYS BEFORE STAYING ILLUMINATED PERMANENTLY. THE DIAGNOSTIC CODES INDICATE FAILURE OF THE SUPPLEMENTAL RESTRAINT SYSTEM. TROUBLESHOOTING, RESEARCH, AND DIAGNOSTICS HAVE REVEALED POOR ELECTRICAL CONNECTIONS AT VARIOUS CONNECTORS THROUGHOUT THE VEHICLE FOR THE SRS SYSTEM. DEALER SERVICE HAS INDICATED POTENTIAL FAILURE OF THE ENTIRE SAFETY SYSTEM TO PERFORM ITS FUNCTION (PRE-TENSIONERS, AIRBAG DEPLOYMENT, ETC) IF THIS LIGHT IS ILLUMINATED.

May 13, 2015

SEAT BELTS

2 complaints

TL* THE CONTACT OWNED A 2011 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 25 MPH AND CROSSING AN INTERSECTION, ANOTHER VEHICLE STRUCK THE CONTACT'S VEHICLE ON THE FRONT DRIVER SIDE. THE AIR BAGS DEPLOYED, BUT THE SEAT BELT PRETENSIONER FAILED TO LOCK. THE CONTACT'S HEAD STRUCK THE WINDSHIELD. THE CONTACT RECEIVED HEAD, BACK, NECK, AND KNEE INJURIES, WHICH REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TOWED AND DEEMED DESTROYED. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

May 31, 2017

Crash: 1

Injuries: 1

2011 FORD EXPLORER XLT: THIRD ROW SEAT BELT COMPARTMENT ON BOTH PASSENGER AND DRIVER SIDES, LEAKING WATER. SEATS ARE LEATHER. NOTICED WHEN CHILD BOOSTER SEATS WERE SOAKED AFTER IT RAINED. NOW CONCERNED IF METAL HAS RUSTED IN ANY OF SEAT BELT MECHANISMS. VEHICLE PURCHASED FROM FORD DEALER, FORD VERIFIED USED VEHICLE. PURCHASED VEHICLE APPROXIMATELY 70,000 MILES. ISSUE OCCURRED AT 105,000 MILES

Oct 04, 2016

STEERING,SERVICE BRAKES,ENGINE

2 complaints

I PURCHASED MY VEHICLE IN MARCH OF 2016. I FIRST HAD ISSUES WITH THE BRAKING SYSTEM. I HEARD SCREECHING AND WHIRRING AS I DROVE THE VEHICLE. NEXT, I HAD ISSUES WITH THE BATTERY, BATTERY ACID LEAKED ALL OVER THE BATTERY, CORROSION BUILT UP ON THE BATTERY. MOST RECENTLY, AFTER SERVICING MY VEHICLE, THE POWER STEERING LOCKED UP. THE COMPUTER READ THAT THERE WAS POWER STEERING FAULT. I DON'T UNDERSTAND HOW I WAS ABLE TO PURCHASE A VEHICLE OFF THE DEALERSHIP LOT WITH ALL OF THE ISSUES THAT THE VEHICLE HAD.

Apr 01, 2017

I FIRST BEGAN EXPERIENCING BRAKING AND BATTERY ISSUES 3 TO 4 WEEKS AFTER THE PURCHASE OF MY VEHICLE. I TOOK THE VEHICLE IN FOR SERVICING OF THE BRAKING AND BATTERY ISSUES. I WAS INFORMED BY THE SERVICE ADVISOR THAT I SHOULD RETURN THE VEHICLE TO DEALERSHIP FOR REPAIRS DUE TO THE MULTIPLE ISSUES WITH VEHICLE. AT THAT TIME, I LEARNED THAT THERE WAS LEAKAGE FROM THE UPPER PORTION OF THE ENGINE. THE DEALERSHIP ADDRESSES SOME BUT NOT ALL ISSUES RELATED TO THE VEHICLE. NEXT, I RECEIVED AN EMAIL FROM THE DEALERSHIP STATING THE VEHICLE WAS DUE FOR FACTORY RECOMMENDED SERVICING. I MADE AN APPT. THE NEXT DAY, THE LOW BATTERY LIGHT CAME ON. CALLED DEALERSHIP, NO RESPONSE. ONE AND A HALF WEEKS LATER, THE BATTERY WAS DEAD. CALLED TRIPLE A. BATTERY HAD BATTERY ACID AND CORROSION EVERYWHERE. A RED SOLUTION WAS SPRAYED ON THE BATTERY TO PREVENT LEAKAGE. BUT IT DIDN'T WORK THAT WELL. INFORMED DEALERSHIP AT THE TIME OF SERVICE, THAT THE POWER STEERING SERVICE LIGHT HAD COME ON. FIVE DAYS LATER, I COULDN'T TURN THE STEERING WHEEL. BOTH SERVICE ADVISORS STATED THAT VEHICLE SHOULDN'T HAVE BEEN PLACED ON LOT FOR SALE. I NO LONGER FEEL SAFE IN THIS VEHICLE. AS I HAVE TWO MINOR CHILDREN. THE DATE OF ONSET WOULD'VE BEEN 04/08/2016. THERE IS ANOTHER PHOTO, HOWEVER, THERE WAS NOT ENOUGH ROOM TO INCLUDE.

Apr 01, 2017

STEERING,ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES

2 complaints

AFTER HAVING EPAS REPLACED (@HALL FORD ELLIZABETH CITY, NC) UNDER RECALL 15N01 AFTER COMPLETE POWER STEERING FAILURE. WE BEGAN A 700 MI. ROAD TRIP HOME AND BEGAN TO EXPERIENCE SPONTANEOUS TRACTION CONTROL INTERACTION WITH OUR DRIVING INPUT WHICH AFFECTED EITHER POWER DISTRIBUTION TO THE AXELS, BRAKING ABILITY, AND STEERING ABILITY. AFTER MAKING IT NEARLY 300 MILES THE ELECTRONIC STABILITY CONTROL COMPLETELY WENT OUT ALONG WITH WHAT FELT LIKE ABS CONTROL SEEMED LIKE IT INTERVENED SPORADICALLY. WE ALSO RECIEVED A DASH PROMPT THAT THE FUEL FILLER INLET NEEDED CHECKED AS WELL. UPON ARRIVAL TO A FORD DEALER ALONG OUR ROUTE (SHEEHY FORD, WARRENTON, VA) THEY PULLED THE CODES LISTED AND APPEARED TO BE A LITANY OF CODES NEARLY A PAGE AND A HALF LONG. THEY CLEARED THE CODES AND DROVE THE VEHICLE. AFTER DRIVING THE VEHICLE AROUND THE BLOCK THE TRACTION CONTROL BEGAN TO ACT INTERMITTENTLY WITHOUT LOSS OF TRACTION. THEY CAME BACK AND CHECKED FOR ERROR CODES AND THE "STEERING POSITION SENSOR WAS AT FAULT" THEY WENT THROUGH RE-CALIBRATED THE EQUIPMENT INSTALLED AND CLEARED OUT THE CODES AND DROVE WITHOUT ANY ISSUES. WE THEN CONTINUED ON OUR REMAINDER OF OUR TRIP WITHOUT ANY FURTHER ISSUES. UPON ARRIVAL TO OUR HOME DESTINATION THE FOLLOWING DAY WE BEGAN TO AGAIN HAVE TRACTION CONTROL INTERVENING WITH DRIVER INPUT WHEN NOT NEEDED WHERE IT APPEARS TO BE SHIFTING POWER FROM AXLE TO AXLE OR APPLYING BRAKING TO AID IN TRACTION CONTROL. I HAVE ALSO NOTICED THAT THAT REAR VIEW CAMERA DISPLAYS THE POSTION OF THE DRIVER WHEEL IN RELATION TO THE WHEEL PATH IN REVERSE BUT APPEARS INTERMITTANT AS IF THERE IS A NOT A CONTINUOUS CONNECTION WITH THE SENSOR. TAKING TO OUR LOCAL FORD DEALER HERE MONDAY 4-4-16 TO HAVE THEM THOROUGHLY GO THROUGH THE VEHICLE BUT APPEARS TO CONTINUE TO BE AN ISSUE WITH THE ELECTRONIC POWER STEERING ASSIST. ALL ISSUES ARE PRESENT WHEN TRAVELING AT SPEED AND TURNING

Apr 03, 2016

2011 FORD EXPLORER WAS JUST RETURNED TWO WEEKS AGO FOR NATIONAL RECALL ON ELECTRONIC POWER STEERING CONTROL MODULE FAILURE. ON AUGUST 21ST AT 9:30 AM MY WIFE WAS APPROACHING A RED LIGHT. SHE APPLIED THE BRAKES AND FELT AN IMMEDIATE POWER LOSS ISSUE WITH THE BREAKS. SHE IMPACTED THE VEHICLE IN FRONT OF HER AROUND 15 MPH. AIR BAGS WERE NOT DEPLOYED AT TIME OF ACCIDENT. SHE DID NOTICED THE TERRAIN MANAGEMENT FAILURE LIGHT WAS ILLUMINATED AT TIME OF IMPACT. MY WIFE DID NOT FEEL THE ANTI LOCK BRAKES ENGAGE, NOR WERE THERE ANY SKID MARKS VISIBLE ON THE ROAD. MINOR FRONT END DAMAGE IS EVIDENT AND RADIATOR WAS LEAKING FLUID. INSURANCE COMPANY HAS BEEN NOTIFIED ABOUT RECENT RECALL. *TR

Aug 21, 2014

Crash: 1

POWER TRAIN,UNKNOWN OR OTHER

2 complaints

WHILE DRIVING AT 35 MPH GOING STRAIGHT AHEAD, THE CAR SUDDENLY SHIFTED INTO REVERSE, CAUSING THE VEHICLE TO SKID TO A STOP, THIS LOCKED UP THE FRONT AND REAR WHEELS SKIDDING ON THE PAVEMENT. THERE WAS TRANSMISSION FLUID ON THE GROUND WHEN IT WAS TOWED TO THE DEALERSHIP. ALSO THE REAR VIEW CAMERA CAME ON AT THE SAME TIME SO THE OCCUPANTS COULD SEE THE CAR BEHIND THEM, ALSO INDICATING THE CAR WAS IN REVERSE. THE TRANSMISSION LEVER/HANDLE WAS STILL IN DRIVE. I BELIEVE THIS WAS SOME TYPE OF ELECTRONIC MALFUNCTION, BUT NO WARNING LIGHTS CAME ON, AND ON THE COMPUTERIZED VEHICLE CHECK IT INDICATED NO MALFUNCTIONS, TEMPORARILY THE HILL ASSIST LIGHT CAME ON BUT WENT OUT SHORTLY BEFORE THE CAR WAS TOWED. THE CAR COULD NOT BE SHIFTED INTO ANY GEAR, NOR MOVE FORWARD OR BACKWARDS. THE FRONT WHEELS WERE LOCKED AND SKIDDING AS IT WENT ONTO THE TOW TRUCK. THE REAR WHEELS MOVED AT THIS POINT AND IT IS A FOUR WHEEL DRIVE VEHICLE.

Nov 01, 2015

I WAS DRIVING MY 2011 FORD EXPLORER ON THE CAUSEWAY- HEAVY TRAFFIC MOVING AT ABOUT 50 - 55 MPH. APPROACHING FIRST BRIDGE INCLINE, SPEED DROPPED TO APPROX 1 MPH CREEPING ALONG, ACCELERATOR PRESSED TO FLOORBOARD. ORANGE WRENCH ICON APPEARED ON INSTRUMENT PANEL. PUT ON HAZARDS TO NOTIFY TRAFFIC. CARS PULLING AROUND TRYING TO AVOID HITTING MY VEHICLE. NOT ENOUGH ROOM ON EMERGENCY LANE OF BRIDGE TO PULL COMPLETELY OUT OF TRAFFIC LANE - MADE IT TO TOP OF BRIDGE - COASTED DOWN HALF WAY IN EMERGENCY LANE AND LEFT LANE UNTIL REACHED BOTTOM OF BRIDGE AND COULD PULL OVER TO GRASSY SIDE OF ROAD. TURNED VEHICLE OFF. WAITED, THEN RESTARTED VEHICLE. DROVE DIRECTLY TO FORD DEALER WHO HOOKED IT UP TO COMPUTER AND FOUND NOTHING WRONG. THEY TEST DROVE IT, THEN CALLED TO SAY THEY COULD FIND NOTHING. I ASKED THEM TO SERVICE THE CAR AS IT WAS TIME. THEY KEPT THE CAR OVER THE WEEKEND TO SERVICE IT ON MONDAY 10/27/14 AND TESTED THE SYSTEM ONE MORE TIME- STILL FOUND NOTHING WRONG. I PICKED THE CAR UP 10/27/14 AND LEFT DEALERSHIP AT ABOUT 1230 AND BY ABOUT 1245 THE SAME THING HAPPENED AGAIN- NO ACCELERATION - JUST ABOUT 1 MILE AN HOUR AND VEHICLE RUNNING SLIGHTLY ROUGH- WRENCH APPEARED AGAIN. I PULLED OVER IN TO A PARKING LOT, TURNED THE ENGINE OFF; RESTARTED AND DROVE BACK TO THE DEALERSHIP. THIS TIME THEY RAN A DIFFERENT COMPUTER CHECK AND GOT A CODE THAT SUGGESTED BRAKES AND ACCELERATOR DEPRESSED AT SAME TIME. NO, I DO NOT TRY TO BRAKE AND ACCELERATE AT THE SAME TIME. THE SERVICE DEPARTMENT DROVE MY CAR FOR ABOUT 30 MILES TRYING TO RECREATE THE INCIDENT. THEY STILL CAN FIND NOTHING WRONG WITH THE VEHICLE. I PICK UP MY VEHICLE AFTER WORK TODAY. MY CAR RECEIVES REGULAR SERVICE AT THE DEALERSHIP AND IS NOT DRIVEN ROUGHLY. I AM CONCERNED THAT THIS COULD HAPPEN AGAIN. WRENCH ICON INDICATES POWER TRAIN ISSUE.

Oct 29, 2014

UNKNOWN OR OTHER,SERVICE BRAKES,ENGINE

1 complaint

Unknown

Nov 20, 2025

SUSPENSION,STRUCTURE

1 complaint

The contact owns a 2011 Ford Explorer. The contact stated that while driving at an undisclosed speed, the A-pillar trim on the driver’s side windshield started to detach. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 21V746000 (Suspension); however, the parts to perform the recall repairs were not yet available. The local dealer was contacted and confirmed that parts were not yet available and were on back order. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was not available.

Oct 23, 2025

BACK OVER PREVENTION

1 complaint

The contact owns a 2011 Ford Explorer. The contact stated that the rearview camera displayed a distorted image while the vehicle was in reverse(R). The contact stated that the failure obstructed the driver's visibility, which prevented the driver from safely operating the vehicle. The message "Camera not Available - Contact Local Dealer" was displayed. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 125,000.

Jun 25, 2025

AIR BAGS,STRUCTURE

1 complaint

The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the air bag warning light was illuminated. The vehicle was taken to the dealer for the air bag warning light being illuminated and the dealer diagnosed that the front passenger’s side air bag sensor had failed and needed to be replaced. The dealer informed the contact that the part was ordered; however, the vehicle was not repaired. The dealer was contacted regarding NHTSA Campaign Number: 24V031000 (Structure); in February 2024 and the contact was informed there were no parts available for the recall repair. In July 2024 the contact received a letter stating that parts were available, and an appointment was scheduled for October 2024. At the time of the appointment, the dealer informed the contact that the recall repair could not be performed due to parts not being available. The manufacturer was made aware of the issue, and a case was opened. The failure mileage was approximately 30,000. Parts distribution disconnect.

Mar 25, 2025

UNKNOWN OR OTHER,VISIBILITY/WIPER

1 complaint

The exterior A-pillar trim panel on my 2011 Ford Explorer has detached multiple times while driving. The first incident occurred when the original panel flew off into traffic, creating a safety hazard for other road users. Since then, I have been using a temporary replacement panel, which also continues to detach while driving, further escalating the safety risk. I have been attempting to resolve this issue for over three months by contacting every Ford dealership in the Bay Area. Each dealership claims they do not have the parts necessary to complete the recall repair, despite Ford's assertion that parts are available. As a result, the recall remains incomplete, and the issue persists, creating ongoing safety risks for myself and others on the road. No warning lamps or messages preceded the incidents. The problem has not been reproduced or inspected by a dealer due to the unavailability of parts. This unresolved recall places myself and other road users at continued risk of potential crashes caused by flying debris from my vehicle.

Nov 16, 2024

STEERING,VEHICLE SPEED CONTROL

1 complaint

Vehicle became very hard to steer and warning lights came on warning of steering module failure.

May 01, 2024

UNKNOWN OR OTHER,SERVICE BRAKES,FUEL/PROPULSION SYSTEM

1 complaint

Hidráulic problem

Apr 01, 2024

AIR BAGS,SEAT BELTS,STRUCTURE

1 complaint

Driver side window panel flew off during my drive on the interstate directly after I noticed it being loose for the first time. 3rd row seatbelts leak when it rains on both sides. Rear backup camera is opposite/flipped and goes in and out. Trunk will close on you after opening it up with the car not running. It will not sense movement when the car is off and continues to shut resulting in harm.

Mar 02, 2024

POWER TRAIN,WHEELS,VISIBILITY/WIPER

1 complaint

The contact owns a 2011 Ford Explorer. The contact stated that while the windshield wipers were in the on position, the wipers went off the vehicle and had to be pushed back into place. There was an unknown yellow warning light illuminated. The contact stated that while making a turn, the driver's and passenger's front wheels detached on two occasions. The vehicle was taken to an independent mechanic and the vehicle received an unstated repair. There was an abnormal sound while driving at various speeds. While shifting gear, the vehicle jumped. The vehicle was taken to the local dealer however, the result of the diagnostic test was unknown. The vehicle was repaired. The manufacturer was not contacted. The failure mileage was approximately 104,000.

Mar 01, 2024

STEERING,ELECTRICAL SYSTEM,BACK OVER PREVENTION

1 complaint

The Electronic power steering went out for the third time while trying to park at grocery store parking lot. We have paid for 3 replacements and reprogramming now for the 3rd time it’s out again.

Jul 26, 2023

ELECTRICAL SYSTEM,AIR BAGS,ENGINE

1 complaint

The dash lights go off then it's says starting rebot. Air bag lights stay on. Check engine light on says miss firng. All Carfax report was forged. Dealer said needs new engine but was not told by seller. No one will fix it they say not worth the price for car. I over paid big time. Got lied too.

May 22, 2023

SUSPENSION,ELECTRICAL SYSTEM

1 complaint

on december of 2022 the power steering go out during I was driving with my family and the steering it was very hard to keep control of the steering I almost lost control of the vehicle the good news is no car it was around me I try to do my best to get home safety .after the mechanic diagnostic he mention it this ..ON MAY 2014 FORD COMPANY ISSUE A RECALLFOR THE 2011 -2013 FOR EXPLORER FOR A DEFECT ON THE POWER STEERING SYSTEM ..so I contact ford and they tell me I have to repair the total out of my packet becouse they cant see any recall but my car it was made during the time frame the recall it was made I really not understand why they can even look this problem I cant imaging if I was on the higway on high speed I really scared after I deal with this problem

Jan 19, 2023

STEERING,SUSPENSION,ELECTRICAL SYSTEM

1 complaint

My 2011 ford explorer steering randomly went out . As I researched I realized that there was a safety recall 14s06 for that particular car. Apparently that recall was announced in 2014( before I purchased the vehicle) the previous owner took the truck to the dealership the have the pscm checked and no codes came back so it was only reprogrammed which is suppose to prevent steering loss which is what I am currently dealing with. The dealership is not trying to replace the part free of charge as stated in warranty although they know this is serious safety issue on this vehicle . They are trying to charge me 2800.00 to have the part replaced.

Jan 05, 2023

STEERING,SUSPENSION,UNKNOWN OR OTHER

1 complaint

NO INCIDENTS YET. I HAVE HAD A POWER STEERING FAULT WARNING CAME ON. IT IS OFF NOW I HAVE CONTACTED FORD IN DETROIT, RECALL EXPIRED EVENTHOUGH MY CAR HAS ONLY 124,100 MILES ON IT.IT WILL COST ME $2300. TO FIX IT WHICH I DO NOT HAVE. I WAS NEVER TOLD ABOUT A RECALL ON THIS. I PURCHASED THIS USED CAR IN DEC,2021 AT KEARNEY MOTORSPORTS IN LOUISVILLE KY. NOW I HAVE RECEIVED A RECALL NOTICE ON THE SUSPENSION. I FIND THIS CAR VERY UNSAFE AND REALLY DO NOT KNOW WHAT TO DO ABOUT THIS, ESPECIALLY THE POWER STEERING. PLEASE ADVISE, OH I DID REPORT THIS TO KYDOT.

Apr 27, 2022

STEERING,ELECTRICAL SYSTEM,EXTERIOR LIGHTING

1 complaint

THE TRUCK WAS DRIVING SMOOTHLY AND I TURNED IT OFF, TEN MINUTES LATER THE TRUCK POWER STEERING WAS RIDICULOUSLY THOUGH I COULD BARELY DRIVE BACK HOME,STILL CAN'T USED THE TRUCK,CALLED THE DEALERSHIP AND TOLD ME THAT THIS TRUCK DOES HAS A ELECTRICAL POWER STEERING RECALL BUT THE MILEAGE WAS OVER 1000 MILES OF THE MILES THATS IN THE RECALL SYSTEM, COULDN'T IMAGINE IF THAT SITUATION HAPPENED WHILE I WAS ON THE HIGHWAY IT WOULD'VE OCCURRED AN ACCIDENT I DONT THINK ITS FAIR THAT THIS MODELS HAVE A RECALL AND THE DEALERSHIP ARE NOT DOING NOTHING ABOUT IT, I REALLY NEED SOME HELP I HAVE KIDS AND I CANNOT ENDANGER THEM BY THIS MISTAKE THE FABRICATORS DONE.

Mar 09, 2021

STEERING,POWER TRAIN,UNKNOWN OR OTHER

1 complaint

MY POWER STEERING TOTALLY WENT OUT. IT KEPT SAYING POWER STEERING FAULT AND JUST STOPPED WORKING. THEN IT STARTED SAYING SOMETHING ABOUT TRAC TERRAIN FAULT OR SOMETHING. I'VE ONLY HAD THIS CAR SINCE 2018 AND THEN FOUND OUT TODAY THERE WAS A RECALL ON THEM FOR POWER STEERING. WE BOUGHT OUR CAR IN OKLAHOMA AND NOW LIVE IN ALABAMA. THE POWER STEERING HAS BEEN WEIRD ON ME BEFORE BUT TURNING OFF THE CAR AND RESTARTING IT WOULD FIX IT, BUT IT HAS WENT OUT SAYING FAULT WHILE I WAS GOING AROUND A TURN AND I HAD TO BRAKE QUICKLY, THROW ON MY HAZARDS, TURN OFF THE CAR AND RESTART IT. BUT NOW NOTHING IS FIXING IT, I HAD TO TOW IT TO MY HOUSE FROM AN HOUR AWAY BECAUSE I WAS STUCK AT WORK AT 1AM. I AM THE ONLY PERSON IN MY FAMILY ABLE TO WORK AND WORK ABOUT 52HOURS A WEEK AND DON'T KNOW I CAN AFFORD TO FIX THIS ISSUE THAT APPARENTLY WAS KNOWN BUT NOT FIXED IN MY VEHICLE BEFORE IT WAS SOLD TO ME (NOT YOUR FAULT, THE DELEARSHIPS FAULT, BUT THEY ARE 10 HOURS AWAY...)

Nov 12, 2020

STEERING,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

1 complaint

VEHICLE TURNS OFF AUTOMATICALLY WHILE IN MOTION. COMPLETE SHUT OFF

Jul 11, 2020

STEERING,ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE DRIVING, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO JONES FORD CASA GRANDE (1932 N PINAL AVE, CASA GRANDE, AZ 85122, (520) 836-3100) WHERE IT WAS DIAGNOSED THAT THE ENGINE BLOCK WAS MIXING WITH THE OIL. THE VEHICLE WAS REPAIRED. ON ANOTHER OCCASION, THE POWER STEERING WAS LOCKING CONSISTENTLY, AND THE INTERLOCK AND ADVANCETRAC WARNING INDICATORS ILLUMINATED. THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE SAME DEALER AND WAS REPAIRED AGAIN. THE CONTACT STATED THAT THE POWER ASSIST WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO THE SAME DEALER WHERE THE GEARS AND ALIGNMENT WERE RESET. THE CONTACT ALSO MENTIONED THAT THE CHECK ENGINE WARNING INDICATOR CONTINUED TO ILLUMINATE. THE VEHICLE WAS TAKEN BACK TO THE SAME DEALER WHERE IT WAS DETERMINED THAT AN UNKNOWN PART NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE CONTINUED. THE CONTACT STATED THAT THE FUEL FILTER NECK ASSEMBLY ALSO NEEDED TO BE REPLACED. THE EVAPORATOR CANISTER WAS REPLACED AND THE TECHNICIAN INFORMED THE CONTACT THAT THE FUEL TANK WAS LEAKING FUEL. THE VEHICLE WAS NOT REPAIRED BECAUSE THE FUEL TANK WAS NO LONGER MANUFACTURED BY FORD. THE CONTACT STATED THAT THE VEHICLE REMAINED AT THE DEALER AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS APPROXIMATELY 48,000.

Dec 16, 2019

STEERING,SUSPENSION,STRUCTURE

1 complaint

RIGHT FRONT AXLE/CONTROL ARM FAILING (SNAPPED CLEANLY IN 2) 3 TIMES WITHIN 2 YEARS. FIRST TIME MAY HAVE BEEN SUBSEQUENT TO LOW SPEED FRONT END COLLISION. SECOND & THIRD TIMES DRIVING LESS THAN 25 MPH WITH NO COLLISION UNTIL AFTER HEARING THE SNAP & SUBSEQUENT LOSS OF STEERING. SECOND TIME FAILURE OCCURRED WHILE ACCELERATING FROM A FULL STOP & TURNING LEFT ON A CITY STREET.THIRD TIME I'D BEEN DRIVING STRAIGHT APPROXIMATELY HALF A MILE ON A CITY STREET WITH SPEED NO GREATER THAN 25 MPH. LAST TWO REPLACEMENT/REPAIR DONE BY PROGRESSIVE INSURANCE CERTIFIED REPAIR FACILITY.

Jul 26, 2019

Crash: 1

STEERING,UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM

1 complaint

I RECENTLY GOT THE 2011 FORD EXPLORER.I KEEP GETTING THIS ODOR SMELL WHEN I FIRST START THE CAR AND ACCELERATE.IT LASTS FOR 5 MINUTES,THEN IT GOES AWAY. ALSO, I RECENTLY STARTED GETTING THIS VIBRATION THROUGH THE GAS PEDAL ON HIGHWAY SPEEDS.THE CAR WILL SHAKE SOMETIMES.WHEN I BRAKE FROM HIGHWAY SPEEDS,MY CAR SHAKES.I HAVE BROUGHT IT TO FORD TWICE AND THEY CHARGE ME $2000 TO REPLACE PARTS,BUT THE PROBLEM STILL PERSISTED.OTHER GARAGE CANT SEEM TO FIGURE OUT WHATS CAUSING IT.

Jul 21, 2019

ELECTRICAL SYSTEM,ELECTRONIC STABILITY CONTROL (ESC),ENGINE

1 complaint

ENGINE DAMAGE DUE TO OVERHEATING. REGULAR AND REQUIRED OIL CHANGES ARE DOCUMENTED AND IMPLEMENTED AS SCHEDULED. NO OTHER ENGINE OR VEHICLE MALFUNCTIONS DURING THE COURSE OF OWNERSHIP, EXCEPT REGULAR OIL CHANGES AND TIRE REPLACEMENT. HOWEVER, ON MAY 15, 2019, VEHICLE SENSOR NOTIFIED OIL CHANGE NEEDED. FIVE DAYS LATER VEHICLE STALLED AT LOCAL MOTEL DUE TO DECREASED POWER, ROCKING MOTION OF CAR AND LUCKILY WE WERE ABLE TO SLOWLY TURN INTO LOCAL HOTEL TO CUT OFF ENGINE AND GET TO SAFETY. AFTER 2 HOURS OF LETTING VEHICLE SET AND COOL DOWN, LOCAL MECHANIC, CHECKED AND SAID WE HAD ENOUGH OIL IN VEHICLE AND NOT SURE WHAT HAPPENED. WAS ABLE TO DRIVE VEHICLE HOME, WITH NO SENSORS ON DASHBOARD ALERTING US TO ANY FURTHER PROBLEMS. THREE DAYS LATER, WITH NO VISIBLE SENSORS FLASHING, CAR BEGAN TO EXHIBIT ROCKING MOTION NOT SPUTTERING MOTION AS I BEGAN TO PULL OUT IN FOUR-WAY INTERSECTION, AND APPROACHING TRAFFIC HEADING MY WAY. THEN SUDDENLY, CAR REGAINED POWER AND WAS ABLE TO CONTINUE TO PROPER LANE AS IF NOTHING WAS WRONG. AFTER TRAVELING ANOTHER 1.6 MILES, CAR JUST STARTING LOSING POWER, CHECK ENGINE, LOW OIL PRESSURE LIGHT, TEMPERATURE LIGHT WARNING ALL APPEARED SUDDENLY. I WAS ABLE TO DRIFT IN MIDDLE LANE IN FRONT OF DEALERSHIP WHERE VEHICLE WAS PURCHASED. I IMMEDIATEDLY TURNED VEHICLE OFF AND WALKED TO DEALERSHIP TO GET HELP IN MOVING VEHICLE OFF THE ROAD. AFTER 3DAYS OF WAITING, DUNCAH DEALERSHIP IN CHRISTIANSBURG, VA, NOTIFED US THAT HEAD GASGET WAS CRACKED AND OVER 7,000 REPAIR BILL WAS NEEDED TO FIX ENGINE REPAIR. AS NOTED BEFORE NO MAJOR PROBLEMS HAS EVER BEEN REPAIRED OR REPLACED REGARDING THIS VEHICLE. DURING THE TWO INCIDENTS REGARDING THE VEHHICLE LOSING POWER, WITHOUT NO VISIBLE VEHICLE SENSOR NOTIFICATIONS IS OF GREAT CONCERN TO US REGARDING OUR SAFETY IN DRIVING OUR VEHICLE. THANKFULLY, WE WEREN'T ON A MAJOR HIGHWAY.

Jun 15, 2019

STEERING,ELECTRICAL SYSTEM,STRUCTURE

1 complaint

THIS VEHICLE WAS IN FOR A RECALL FOR THE ELECTRICAL POWER STEERING. RECALL WAS DONE ON THE VEHICLE IN 2014 NOW IN 2019 AT 150,000 MILES AND AGAIN THE SAME PROBLEM ONLY THIS TIME IT COST ME $1,800 TO GET FIX JUST TO HAVE THE SAME PROBLEM RECUR 3 TIMES. I ALSO GOT INTO AN ACCIDENT. THIS IS MORE THAN A SAFETY ISSUE AND I NOTICE A LOT OF PEOPLE COMPLAINING ABOUT THE SAME THING. WHEN WILL FORD DECIDED TO ADDRESS THIS ISSUE!

Apr 08, 2019

POWER TRAIN,ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

1 complaint

EVERY TIME I GO IN THE HIGHWAY AND I GO 60 MILES PER HOUR I START SMELLING THE EXHAUST SMELL INSIDE MY CAR START FEELING KIND OF DIZZY WITH HEADACHES TOOK THE CAR TO THE DEALER CHECK THAT AND IT'S DOING IT AGAIN EXHAUST SMELL COMES INSIDE OF CAR REALLY BAD

Mar 27, 2019

EXTERIOR LIGHTING,SEAT BELTS,STRUCTURE

1 complaint

WHEN IT RAINS, THE RAIN COMES IN THE TRUCK AND SEEPS THROUGH THE SEATBELTS, THE FRONT PASSENGER INTERIOR HANDLE, THE TWO LIGHTS IN THE TOP OF THE TRUCK (ABOVE THE CONSOLE), THE STERIO IN THE BACK, THE PASSENGER SIDE UNDER THE DASHBOARD, THROUGH THE TRIM OF THE WINDOWS ON DRIVER AND FRONT PASSENGER SIDE, AND INSIDE THE SUNROOF (YES, THE WINDOWS AND SUNROOF IS CLOSED). THIS HAPPENS IF THE TRUCK IS SITTING IN DRIVEWAY, AND WHEN DRIVING. MY GUESS IS THAT SOMETHING WAS NOT PROPERLY SEALED WHEN THE TRUCK WAS BEING MADE.

Dec 15, 2018

POWER TRAIN,VEHICLE SPEED CONTROL,UNKNOWN OR OTHER

1 complaint

I WAS TURNING OUT OF MY ALLEY AND THE CAR HAD NO POWER. WHEN I TRIED TO ACCELERATE NOTHING HAPPENED. I HAD AN ORANGE WARNING LIGHT WITH A WRENCH COME ON THE DASHBOARD. I TURNED THE CAR OFF AND THEN BACK ON AND THERE WAS NO WARNING LIGHT AND NO ISSUE WITH THE ACCELERATION. DEALERSHIP COULDN'T FIND A PROBLEM BUT THIS ISSUE IS ALL OVER THE INTERNET AND THERE IS A RECALL FOR IT BUT NOT FOR MY VIN NUMBER OR YEAR.

Nov 01, 2018

POWER TRAIN,SERVICE BRAKES,ENGINE

1 complaint

I WAS DRIVING MY 2011 FORD EXPLORER (65,000 MILES) WHEN I SUDDENLY LOST ALL POWER TO MY GAS, BREAK AND STEERING WHEEL. LUCKILY I WAS GOING CLOSE TO 10-15 MILES PER HOUR AND I MANAGED TO VEER ONTO SOMEONE'S LAWN AND HIT THE EMERGENCY BREAK. I WAS TOLD THAT THERE WAS OIL LEAKING INTO THE ENGINE THAT CAUSE A COMPLETE ENGINE FAILURE. NO SENSORS WENT OFF PRIOR TO THE INCIDENT AND I HAVE ONLY GOTTEN MY CAR REPAIRED AT THE FORD DEALERSHIP.

Jul 24, 2018

ELECTRICAL SYSTEM,ENGINE

1 complaint

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT HEARD AN ABNORMAL NOISE PROGRESSING FROM THE AREA OF THE ALTERNATOR ASSEMBLY AND THE SERPENTINE BELT. WHILE DRIVING APPROXIMATELY 65 MPH, THERE WAS A SUDDEN LOSS OF POWER. THE CONTACT HAD TO COAST THE VEHICLE SLOWLY TO BE PARKED AT THE CONTACT'S RESIDENCE. THE DEALER (BERGEY'S FORD, 700 N BETHLEHEM PIKE, AMBLER, PA 19002, (215) 793-3700) INDICATED THAT THE VEHICLE WOULD NEED TO BE DIAGNOSED. THE MANUFACTURER INDICATED THAT THERE WAS NO WARRANTY, RECALL, OR MANUFACTURER CAMPAIGN; THEREFORE, NO SOLUTION WAS OFFERED OTHER THAN THE DEALER DIAGNOSING AND REPAIRING THE VEHICLE. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.

Jun 11, 2018

POWER TRAIN,UNKNOWN OR OTHER,SERVICE BRAKES

1 complaint

THE EXPLORER WAS PUT INTO PARK AND LEFT RUNNING IN THE DRIVEWAY AS I WENT INTO THE HOUSE TO GET MY KIDS. WHEN I GOT OUT OF THE CAR IT DIDN'T MOVE AT ALL. WHILE I WAS GETTING MY KIDS TOGETHER I HAPPEN TO LOOK UP AND SEE MY EXPLORER CRASHED INTO A TREE IN THE BACKYARD. I WENT OUT TO SEE WHAT HAPPENED AND THE EXPLORER HAD GONE UP A SLIGHTLY INCLINED DRIVEWAY, DOWN A HILL, THROUGH AND ALUMINUM FENCE, AND CRASHED INTO A TREE. WHEN I OPENED THE DRIVER DOOR THE GEAR SHIFTER STILL SHOWED IN PARK.

Jun 04, 2018

Crash: 1

ENGINE AND ENGINE COOLING,UNKNOWN OR OTHER

1 complaint

ALWAYS GOT TIRED WHEN I DROVE THE VEHICLE. I NEVER FELT COMPLETELY ALERT WHEN I DROVE IT. I WOULDN'T TAKE MY GRANDCHILD ANYWHERE WITH ME IN THAT VEHICLE BECAUSE I DIDN'T FEEL COMFORTABLE OR SAFE DRIVING IN IT WITH OTHERS. ONE DAY I GOT REALLY LIGHT HEADED AND THE NEXT THING I KNEW IS I WRECKED THE VEHICLE INTO THE SIDE OF AN OVER PASS WALL AT 35 MPH. I NO LONGER HAVE THE VEHICLE, BUT I NEVER KNEW WHY IT HAPPENED. DID THE VEHICLE HAVE A CABIN MONOXIDE LEAK? WHEN I HAD THE ACCIDENT I WAS SO OUT OF IT THAT I THOUGHT A CAR WAS BESIDE ME OR SOMETHING. ALL I KNOW IS I NEVER FELT SAFE DRIVING IT WITH THE WAY IT MADE ME FEEL...UPDATED 12/13/17 *BF *TR

Nov 30, 2017

Crash: 1

Injuries: 1

SUSPENSION,VISIBILITY/WIPER

1 complaint

MY VEHICLE WAS ON THE ROAD IN MOTION WHEN I HEARD A CREAKING/CLANKING NOISE ON THE FRONT RIGHT SIDE NEAR THE TIRE. AFTER TAKING MY VEHICLE TO THE DEALERSHIP TO DETERMINE WHAT THE CAUSE OF THE NOISE WAS, I WAS ADVISED THAT IT WAS A FAULTY FRONT RIGHT STRUT AND SPRING ASSEMBLY. I HAD MY MECHANIC REPLACE BOTH THE FRONT AND LEFT STRUTS. AFTER DOING A LOT OF RESEARCH ON THE INTERNET FROM OTHER FORD EXPLORER OWNERS , I BELIEVE THAT STRUT AND SPRING ASSEMBLY ARE MANUFACTURE DEFECTS. WHILE BACKING UP MY VEHICLE, I NOTICED THAT THE BACK UP CAMERA WAS BLANK AND NOT WORKING. AFTER MONITORING THE OPERATION OF THE BACK UP CAMERA, IT HAS BECOME AND INTERMITTENT ISSUE, IT COMES AND GOES. NOW, MY BACK UP CAMERA IS WORKING BUT THE BACK UP CAMERA GUIDELINES ARE NOT THERE. AFTER READING MANY BLOGS, THERE' S ALOT OF FORD EXPLORER OWNERS WHO ARE HAVING SIMILAR ISSUES WITH THE BACK UP CAMERA. THIS IS A SAFETY ISSUE AND I BELIEVE IT IS A MANUFACTURE DEFECT.

Jul 02, 2017

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE

1 complaint

CAR WAS FINE THEN ALL OF A SUDDEN OVER HEATING SIGN WENT ON IN THE CAR . I PULLED OVER ON THE FREEWAY CALLED A TOW TRUCK BECAUSE I WAS TOLD NOT TO DRIVE THE CAR. I HAD IT TOWED TO MY HOUSE HAD A PROFESSIONAL MECHANIC LOOK AT IT AT MY HOUSE I WAS THEN TOLD THAT THERE WAS A LEAK AND THE WATER TANK WAS NOT HOLDING WATER BECAUSE OF IT. THE NEXT DAY I WENT TO MY CAR I TURNED IT ON AND CHECK ENGINE LIGHT WAS ON. I THEN TURNED OFF THE CAR CAUSE I DID NOT WANT TO CAUSE ANYMORE DAMAGE. THE MECHANIC CAME BACK TO MY HOUSE AND TOLD ME IT WAS NOW LEAKING WATER AND OIL TO TAKE IT IN RIGHT AWAY. I HAD NO PREVIOUS PROBLEMS WITH MY CAR UNTIL THAT POINT. I TAKE IT TO THE DEALER THEY TELL ME THAT IT WAS AN INTERNAL PROBLEM WITHIN THE ENGINE THAT I, THE DRIVER, COULD NOT HAVE KNOWN ABOUT UNLESS I WAS HAVING PREVIOUS PROBLEMS WITH THE CAR WHICH I WAS NOT. 230 DOLLARS LATER JUST TO TELL ME WHAT IS WRONG WITH THE CAR FORD IS TELLING ME THAT WATER GOT INTO THE ENGINE, TRANSMISSION, ALL OF THE FLUIDS AND PIPES. HOW DOES THIS HAPPEN WITH NO PREVIOUS PROBLEMS WITH THE CAR? I BELIEVE THIS ISSUE NEEDS TO BE RESOLVED I HAVE READ MANY REVIEWS ON THIS MODEL AND THIS ISSUE NEEDS TO BE RECALLED

May 23, 2017

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

THERE ARE ALLOT OF ISSUES GOING ON WITH THE TRUCK WE HAVE JUST HIT AROUND 70K MILES, THIS STARTED A FEW MONTHS AGO THE PASSENGER BACK DOOR IS NOT LATCHING CORRECTLY UPON BEING CLOSED. THE WHOLE ELECTRICAL SYSTEM HAS BEEN FAULTY FOR SOME TIME NOW A/C DOESN'T WORK CORRECTLY/ REMOTES AND LIGHTS ON CAR ON CONSTANTLY FLICKERING... HAPPENS WHILE VEHICLE ISNT IN MOTION AND WHEN IN MOTION

Dec 02, 2016

ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

2011 FORD EXPLORER XLT: FAILURE OF 2011 FORD EXPLORER PASSENGER BLEND DOOR ACTUATOR. HAVE HAD TO REPLACE THIS ACTUATOR THREE TIMES IN 12 MONTHS. FAILURE OCCURS SLOWLY. FAILURE BEGINS WITH CLICKING SOUND PRESENT FOR 10 SECONDS UPON STARTING A/C OR HEATER AND TURNING OFF OF A/C OR HEATER. ISSUE PROGRESSES TO CLICKING SOUND PRESENT THROUGHOUT ENTIRE TIME A/C OR HEATER IS USED. ISSUE THEN PROGRESSES TO COMPLETE FAILURE AND NOT WORKING. VEHICLE PURCHASED FROM FORD DEALER. FORD CERTIFIED USED WITH APPROXIMATELY 70,000 MILES. ISSUE STARTED OCCURRING AT APPROXIMATELY 90,000 MILES.

Oct 04, 2016

AIR BAGS,SEAT BELTS,SEATS

1 complaint

I HAVE MY AIR BAG LIGHT ON MY DASH, AND MY EMERGENCY LIGHTS DO NOT WORK. THIS CAR IS TOO YOUNG TO HAVE SUCH PROBLEMS. MY PASSENGER BACK SEAT BELT CASE IS BROKEN AS WELL. THE STITCHING ON THE SEAT BELT SEEM TO BE TEARING. THIS IS ONLY A 2011 FORD EXPLORER IT IS WAY TO YOUNG FOR ALL THESE MAJOR SAFETY ISSUES. MY MECHANIC CANT FIGURE IT OUT.

Jun 29, 2016

AIR BAGS,VEHICLE SPEED CONTROL,UNKNOWN OR OTHER

1 complaint

I BEGAN EXPERIENCING PROBLEMS WITH THE STEERING WHEEL MOUNTED CONTROLS WHILE DRIVING, WHICH WERE INTERMITTENT. FIRST, THE VOLUME BUTTON FAILED AND THEN CRUISE CONTROL FUNCTIONS FAILED. THE CRUISE CONTROL WOULD SOMETIMES CANCEL ON ITS OWN, CAUSING A SUDDEN UNEXPLAINED LOSS OF SPEED WHILE I THOUGHT IT WAS ENGAGED. THE "RESUME" AND "CANCEL" BUTTON FUNCTIONS ALSO SWAPPED. "RESUME" WOULD CANCEL THE CRUISE CONTROL AND "CANCEL" WOULD RESUME CRUISE. I ONLY FIGURED THIS OUT AFTER PRESSING CANCEL WHILE IN CRUISE CONTROL TO SLOW THE CAR FOR TRAFFIC AHEAD OF ME AND IT DID NOT RESPOND OR SLOW THE CAR. THE CAR CONTINUED AT ITS SET SPEED UNTIL I HIT THE BRAKES TO SLOW IT. THE DIAGNOSIS FOR THE PROBLEM WAS THAT THE CLOCK SPRING HAD FAILED AND IT WAS REPLACED. I FEEL THIS IS A SERIOUS SAFETY CONCERN, ESPECIALLY SINCE THE DRIVER AIR BAG MAY HAVE ALSO BEEN AFFECTED. THIS CAR HAS ONLY 43,000 MILES ON IT. THE FIRST TIME I TOOK THE CAR IN FOR SERVICE, THEY REINSTALLED SOFTWARE WHICH DID NOT FIX THE PROBLEM. I DO NOT YET HAVE THE INVOICE FROM THE REPLACEMENT OF THE CLOCK SPRING BECAUSE IT HAS NOT YET BEEN PAID WHILE I TEST THE REPAIR. THE CLOCK SPRING DID APPEAR TO FIX THE PROBLEM. THE CAR WAS REPAIRED AT PERRY FORD IN SAN LUIS OBISPO, CA.

Dec 02, 2015

STEERING,FUEL/PROPULSION SYSTEM

1 complaint

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE ACCELERATING OVER 65 MPH, THE ODOR OF FUEL WAS PRESENT INSIDE THE VEHICLE. WHILE DRIVING AT VARIOUS SPEEDS, THE POWER STEERING AND POWER TERRAIN MESSAGES DISPLAYED BEFORE THE STEERING WHEEL BECAME LOCKED. THE DRIVER WAS UNABLE TO TURN THE STEERING WHEEL. AFTER SHUTTING THE VEHICLE OFF AND RESTARTING THE ENGINE, THE VEHICLE OPERATED NORMALLY. THE CAUSE OF THE FAILURES WERE NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 80,000.

Oct 21, 2015

TIRES

1 complaint

TL* THE CONTACT OWNS A 2011 FORD EXPLORER EQUIPPED WITH MICHELIN LATITUDE TOUR TIRES, SIZE P245/60R18 (NA). WHILE HAVING THE VEHICLE INSPECTED, THE MECHANIC NOTICED THAT THE TREAD ON ALL FOUR TIRES WAS SEPARATING. THE CONTACT WAS MADE AWARE OF NHTSA CAMPAIGN NUMBER: 13T006000 (TIRES), BUT THE TIRE SIZE WAS NOT INCLUDED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE TIRE AND VEHICLE FAILURE MILEAGE WAS 30,000.

Jul 07, 2015

POWER TRAIN,VEHICLE SPEED CONTROL

1 complaint

REFERENCING PREVIOUS COMPLAINT FOR SAME ISSUE SEE TCN JEN28-49151 TRAVELING TO DINNER AT 7:00PM AGAIN POWERTRAIN WARNING LIGHT CAME ON, ENGINE RAN ROUGH AND SPEED DROPPED TO APPROX. 1 MPH. PULLED OFF SIDE OF ROAD, TURNED OFF CAR. RESTARTED AND CONTINUED ON MY WAY. SAME THING OCCURRED AGAIN THIS MORNING 11/14/14 AT APPROX. 7:15 AM ON WAY TO WORK. THIS TIME THANKFULLY I WAS NOT ON THE CAUSEWAY WHERE TRAFFIC MOVES AT APP 50 - 60 MPH AS I WAS THE FIRST TIME THIS OCCURRED. WHEN THIS HAPPENED TWICE IN OCTOBER I TOOK MY CAR TO THE DEALERSHIP BOTH TIMES AND THEY COULD FIND NOTHING WRONG. THIS CONTINUES TO HAPPEN AND I AM AFRAID THAT ONE DAY MY CAR WILL MALFUNCTION LIKE THIS ON A BUSY ROAD AT A HIGHER SPEED. I WAS LUCKY THE FIRST TIME ON THE CAUSEWAY THAT I MADE IT UP THE BRIDGE TO COAST DOWN ON TO THE GRASS WITHOUT CAUSING AN ACCIDENT. *TR

Nov 14, 2014

VEHICLE SPEED CONTROL,FUEL/PROPULSION SYSTEM

1 complaint

I HAVE A 2011 FORD EXPLORER XLT. THE THROTTLE BODY HAS RECENTLY GONE BAD AND IS STAYING STUCK IN THE OPEN POSITION. THE DEALERSHIP SAYS IT HAS TO BE REPLACED. IT IS AN OBVIOUS SAFETY HAZARD FOR IT TO GET STUCK WHEN GOING AT A HIGH RATE OF SPEED OR EVEN A SLOWER RATE FOR THAT MATTER. THE THROTTLE BODIES WERE A BIG ISSUE FOR THE FORD ESCAPES IN THE PAST SO FORD EXTENDED THE WARRANTY FOR THEM, UNFORTUNATELY IT DOESN'T APPLY TO THE EXPLORER ALTHOUGH IT THE EXACT SAME PROBLEM. *TR

Oct 03, 2014

STEERING,STRUCTURE,SERVICE BRAKES

1 complaint

I WAS DRIVING DOWN THE STREET AT AROUND 20 MPH WHEN THERE WERE CARS THAT SUDDENLY STOPPED. WHEN I WAS BRAKING I FELT AS IF THE STEERING WAS ALLOWING ME TO TURN AND IT HAPPENED SO FAST I FELT AS IF I LOST BRAKING POWER. THEN I HIT THE CAR IN FRONT OF ME HARD. *TR

Sep 15, 2014

Crash: 1

STRUCTURE,VISIBILITY/WIPER

1 complaint

MY VEHICLE WAS PARKED IN THE DRIVEWAY, WHERE IT HAD BEEN SINCE THE PREVIOUS DAY. I OPENED THE FRONT DRIVERS SIDE DOOR AND GOT INTO THE CAR. I PUT THE KEYS INTO THE IGNITION SWITCH AND STARTED THE VEHICLE. AT THIS POINT I CLOSED THE DRIVERS SIDE DOOR. AT THIS MOMENT I HEARD A LOUD "POP" SOUND. I LOOKED INTO THE REAR VIEW MIRROR AND SAW A LARGE HOLE IN THE GLASS OF THE UPPER CENTER PORTION OF THE REAR WINDOW. UPON FURTHER INSPECTION THE REMAINING GLASS WAS SHATTERED AND SPIDER WEBBED. THERE WAS GLASS ON THE GROUND OUTSIDE THE VEHICLE AS WELL AS IN THE REAR COMPARTMENT OF THE CAR. *TR

Sep 07, 2014

SERVICE BRAKES, HYDRAULIC,EXTERIOR LIGHTING,ELECTRICAL SYSTEM

1 complaint

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE DRIVING 25 MPH, THE SPEEDOMETER AND TURN SIGNALS FAILED TO OPERATE. THE DEALER REPLACED THE COMPUTER AND THE TURN SIGNAL CLUSTER. IN ADDITION, THE BRAKE CALIPERS AND ROTORS FAILED DUE TO INSUFFICIENT LUBRICATION. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 19,000.

Aug 11, 2014

FUEL SYSTEM, GASOLINE,ENGINE

1 complaint

WHEN MERGING INTO LANE AND PASSING A CAR ABOUT 3500 RPM EXHAUST GAS ENTERS PASSENGERS CABIN AND EVERYONE INSIDE WILL COMPLAIN OF VERY STRONG ODOR, BREATHING PROBLEM AND HEADACHE. HAD THIS PROBLEM SINCE CAR WAS NEW AND DEALING WITH UNCOMFORTABLE SMELL WITH THE REST OF THE FAMILY. WIFE HAD NUMEROUS TIMES HAVING PROBLEM CONCENTRATING DRIVING BECAUSE THE EXHAUST FUMES OR ODOR IS CAUSING HER TO HAVE HEADACHES AND ALMOST PASSING OUT ON LONG TRIPS. IT IS A HAZARDOUS/DANGEROUS ISSUE. IF FORD CAN HAVE A FIX ON THIS AND IT HAS TO BE SOON. I THINK IT IS THOUSAND OR HUNDRED OF THOUSAND OF FORD VEHICLES OUT THERE THAT HAS THIS PROBLEM. PLS. DON'T WAIT FOR SOMETHING LIKE GM DID. *TR

Jun 21, 2014

FUEL SYSTEM, GASOLINE,POWER TRAIN,ELECTRICAL SYSTEM

1 complaint

UPON MEDIUM TO HEAVY ACCELERATION, SUCH AS ACCELERATING ONTO A FREEWAY, THE VEHICLE CABIN IS FILLED WITH EXHAUST FUMES FROM THE ENGINE. THIS INJURES THE RESPIRATORY SYSTEM OF THE PASSENGERS. THEY ARE WORKING ON A FIX (AFTER MY FAMILY HAS BEEN BREATHING POLLUTED AIR FOR ALMOST TWO AND A HALF YEARS). FORD HAS FINALLY ADMITTED THAT THERE IS A PROBLEM, AND SEND ME A LETTER THAT SAID. [XXX] FORD CUSTOMER SERVICE DIVISION MARCH 7, 2014 [XXX] [XXX] SUBJECT: CUSTOMER CONCERN - EXHAUST ODOR ON 2011-2014 EXPLORER, EDGE OR MKX WE THANK YOU FOR TAKING THE TIME TO DISCUSS THE CONCERN OF EXHAUST ODOR IN YOUR VEHICLE. TO ADDRESS YOUR CONCERN ABOUT EXHAUST ODOR, WE HAVE PERFORMED SEVERAL INSPECTIONS AND SEALING ACTIONS WHERE APPLICABLE ON YOUR VEHICLE TO HELP MINIMIZE THE AMOUNT OF ODOR COMING INTO THE PASSENGER COMPARTMENT. WITH THESE CHANGES YOU MAY STILL EXPERIENCE ODOR UNDER CERTAIN DRIVING CONDITIONS SUCH AS, WHEN PERFORMING WIDE OPEN THROTTLE (WOT) ACCELERATIONS WITH THE CLIMATE CONTROL SYSTEM IN RECIRCULATION MODE. FORD MOTOR COMPANY ENGINEERS HAVE EVALUATED THE AIR ENTERING THE CABIN DURING WORST CASE DRIVING CONDITIONS (SEVERAL WOT ACCELERATIONS WITH THE CLIMATE SYSTEM IN RECIRCULATION MODE). TEST RESULTS INDICATE CABIN AIR QUALITY LEVELS ARE WELL WITHIN THE AMBIENT AIR QUALITY STANDARDS ESTABLISHED BY VARIOUS GLOBAL ENVIRONMENTAL PROTECTION AGENCIES SUCH AS THE U.S. EPA, OSHA, THE KINGDOM OF SAUDI ARABIA PRESIDENCY OF METEOROLOGY & ENVIRONMENT AND THE GOVERNMENT OF DUBAI ENVIRONMENT HEALTH AND SAFETY DIVISION. AGAIN, THANK YOU FOR YOUR TIME. [XXX] CUSTOMER RELATIONS ANALYST PLEASE HELP ME, FORD DON'T WANT TO HELP [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Jun 05, 2014

Injuries: 1

SEAT BELTS,STRUCTURE

1 complaint

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT WATER WAS LEAKING INTO THE VEHICLE THROUGH THE REAR PASSENGER SEAT BELT AREA. THE VEHICLE WAS TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 56,000.

Jun 03, 2014

AIR BAGS,SERVICE BRAKES

1 complaint

AIR BAG LIGHT HAS BEEN ON SEVERAL TIMES. EACH TIME I HAVE TAKEN THE VEHICLE IN FOR SERVICE AND THEY TELL ME EACH TIME THEY FIXED IT. I DRIVE IT SOME AND THE LIGHT COMES BACK ON. IT IS BACK IN THE SHOP FOR THE TENTH TIME I HAVE PAPER TRAILS AND PICTURES TO PROVE IT. I ENDED UP MAKING AN APPOINTMENT THE LAST TIME BUT BEFORE I GOT THERE I HIT A DEER END OF MARCH AT 60 MPH AND THE AIR BAG DIDN'T GO OFF ONCE THE BODY WORK GOT DONE I TOOK IT INTO THE FORD SHOP AND THEY SAID THERE WAS A FAULTY SENSOR WERE THE DEER HIT. THEY REPLACED IT THE I DROVE IT EIGHT MILES AND THE LIGHT CAME BACK ON SO I TURNED AROUND AND THEY ARE TELLING ME THAT THERE ARE NO CODES THIS TIME I HAVE TRIED TO GET THEM TO BUY IT BACK AND THEY WILL NOT. THE REAR BRAKES HAVE LOCKED UP FOUR TIME AND THEY HAVE REPLACE THEM EACH TIME AND IT CONTINUES TO DO THE SAME WITH THEM ALSO. *TR

May 21, 2014

Crash: 1

Injuries: 1

STEERING,VEHICLE SPEED CONTROL,ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

MY WIFE, AND THREE CHILDREN WERE DRIVING AT FREEWAY SPEED WITH THE CRUISE CONTROL SET. THE POWER STEERING FAILED AND THE WARNING LIGHTS CAME ON. THE CONTROLS ON THE STEERING WHEEL LOCKED OUT AND SHE COULD NOT CANCEL THE CRUISE CONTROL. THE LOSS OF POWER STEERING MADE IT DIFFICULT FOR HER TO GET PULLED OVER. SHE TRIED TO CALL ME FOR HELP BUT NO FUNCTIONS OF THE SYNC SYSTEM WORKED. SHE PULLED OVER AND WAITED FOR ME. I RESTARTED THE CAR AND THE STEERING WAS RESET. I DROVE IT TO THE DEALERSHIP. TODAY IS SUNDAY SO I WILL ARRIVE THERE TOMORROW AND HAVE IT EVALUATED. VERY HAZARDOUS AND SCARY FOR MY WIFE AND THE CHILDREN. UNEXPECTED LOSS OF POWER STEERING IS A SAFETY ISSUE THAT CAN CAUSE ACCIDENTS. *TR

May 11, 2014

STEERING,POWER TRAIN,TRACTION CONTROL SYSTEM

1 complaint

I WAS DRIVING ON A MAJOR STREET DURING HEAVY AFTERNOON TRAFFIC. THE STEERING BECAME EXTREMELY DIFFICULT AND I COULD BARELY TURN THE WHEEL. THE WARNING LIGHTS FOR ADVANCED TRACTION FAILURE AND POWER STEERING ASSIST FAULT CAME ON. I ALSO NOTICED THE TERRAIN MANAGEMENT CONTROL WAS NO LONGER ILLUMINATED. I TRIED TO TURN OFF THE ROAD INTO THE DRIVEWAY BUT IT WAS EXTREMELY DIFFICULT. I AM A REASONABLY STRONG ADULT WOMAN AND HAD TO USE ALL MY STRENGTH TO TURN THE WHEEL EVEN SLIGHTLY WHILE SLOWLY MOVING. WHEN I MANAGED TO GET THE CAR INTO A SAFE PLACE I PUT THE CAR IN PARK AND TURNED IT OFF. WHEN THE CAR WAS STARTED AGAIN, IT RETURNED TO NORMAL AND I WAS ABLE TO DRIVE IT. THREE DAYS LATER, THE SAME THING HAPPENED WITH ANOTHER DRIVER WHILE I WAS A PASSENGER. THE OLDER MALE DRIVER HAD SIMILAR DIFFICULTY STEERING AND TURNING THE VEHICLE. I TOOK THE VEHICLE TO THE FORD DEALERSHIP FOR SERVICE. THEY REPAIRED THE RACK AND PINION STEERING FOR AN ESTIMATED COST OF OVER $2000. THE MILEAGE ON THE VEHICLE WAS APPROXIMATELY 36,400 MILES SO ABOUT 400 MILES PAST THE WARRANTY. WE WERE ABLE TO GET FORD TO REDUCE THE COST TO APPROXIMATELY $750, SOME OF WHICH WAS FOR THE ALIGNMENT THAT WAS NECESSARY FOLLOWING THE REPAIR. THIS INCIDENT COULD HAVE BEEN FAR WORSE WITH DEVASTATING RESULTS. I AM A MOM AND GIRL SCOUT LEADER AND TRANSPORT CHILDREN FREQUENTLY THROUGHOUT THE DAY. AT THE TIME OF THE INCIDENT I HAD 4 CHILDREN IN MY VEHICLE. *TR

Mar 28, 2014

STEERING,AIR BAGS,ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

I WAS DRIVING DOWN THE STREET AT 55 MPH WHEN THE 'POWER STEERING ASSIST FAULT' DISPLAYED ON THE DASHBOARD INTERIOR DISPLAY. THE STEERING WHEEL IMMEDIATELY LOCKED UP & I LOST COMPLETE CONTROL OF THE VEHICLE & DRIFTED TO THE RIGHT. I STEPPED ON THE BRAKES TO AVOID CRASHING & TURNED THE CAR OFF. ONCE I TURNED THE CAR BACK ON THE FAULT WAS NO LONGER THERE & I DROVE HOME. I CALLED THE FORD DEALERSHIP & MADE AN APPOINTMENT TO GET THE VEHICLE CHECKED THE NEXT DAY. LATER ON THAT SAME DAY, MY WIFE & I HAD AN APPOINTMENT. HOWEVER, WHEN WE STARTED THE VEHICLE UP, THE SAME FAULT WAS IMMEDIATELY DISPLAYED & THE STEERING WHEEL LOCKED UP. I KEPT TURNING THE CAR OFF & TRYING TO RESTART, BUT THE FAULT WOULD NOT GO AWAY. I HAD TO GET MY VEHICLE TOWED TO THE FORD DEALERSHIP. I DID SOME RESEARCH ONLINE ONLY TO DISCOVER THAT I WAS NOT THE ONLY FORD OWNER THAT HAD THIS PROBLEM. SEVERAL OTHERS HAD THE SAME ISSUE. THIS FINDING PROMPTED ME TO LOOK ON THE FORD WEBSITE TO SEE IF THERE WAS ANY RECALL BUT THERE IS NONE. THE FORD DEALERSHIP QUOTED ME FOR AN 'AIR BAG SAFETY FAULT', ELECTRICAL & VALVE MALFUNCTION, AFTER RUNNING A DIAGNOSTIC TEST ON MY VEHICLE. I WAS DEEPLY CONCERNED BECAUSE THE 'AIR BAG FAULT' NEVER DISPLAYED DUE TO THE OTHER FAULT. THE ESTIMATED COST WAS OVER $3,000. ALSO, I HAD TO RENT A VEHICLE IN THE INTERIM. I ASKED ABOUT RECALLED PARTS & LEGAL ACTION WHEN I WAS AT THE DEALERSHIP BUT NO ONE HAD ANY INFORMATION. WHEN I WENT TO PICK UP MY VEHICLE, THE FORD DEALERSHIP SAID THEY WOULD PAY FOR THE RENTAL & THEY MADE CONTACT WITH FORD COMPANY. THE FORD COMPANY ALLEGEDLY EMAILED THE FORD DEALERSHIP & TOOK $1,000 OFF THE TOTAL COST. I HAVE A WIFE & A BABY. THIS IS OUR ONLY MODE OF TRANSPORTATION. I FEAR FOR THE SAFETY OF MY FAMILY IN THIS MAKE OF VEHICLE & I WOULD LIKE FOR FORD TO INVESTIGATE THIS ELECTRICAL ISSUE FURTHER & RECALL ITS PARTS. PLEASE HELP US & ALL OTHERS WITH THIS ISSUE. *TR

Jan 27, 2014

STEERING,VEHICLE SPEED CONTROL,WHEELS

1 complaint

I WAS GETTING READY TO TURN INTO THE PARKING LOT .. WHEN 2 SETS OF LIGHTS CAME ON ..THE SYSTEM INDICATORS CAME UP .. ONE INDICATING THE POWER STEERING ERROR AND ANOTHER INDICATING THE POWER STEERING LOCKED ... THEN THE STEERING WHEEL BECAME VERY HARD TO TURN .. MAKING SO VERY HARD TO TURN INTO A PARKING SPACE .. SOMEONE HAD TO PUSH ME INTO THE PARKING LOT OUT OF THE WAY .. LATER TO CALL FORD DEALERSHIP DOESN'T WANT TO ASSIST ME WITH THIS PROBLEM ... I DRIVE A 2011 FORD EXPLORER .. THE CAR IS 2 YEARS OLD . I REVIEWED OTHER CONCERNS OF THIS MATTER .. IS THERE A RECALL ... *TR

Nov 05, 2013

STEERING,EXTERIOR LIGHTING,ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

WHILE DRIVING, POWER STEERING ASSIST ABRUPTLY FAILS, AS DOES ADVANCE TRAC STABILITY CONTROL. THE VEHICLE BECOMES MUCH HARDER TO CONTROL. IF THE CAR IS IN A TURN WHEN THE STEERING FAILS, THE STEERING WHEEL LURCHES AND TRIES TO RE-AIM THE VEHICLE STRAIGHT AHEAD, DISRUPTING THE TURN. DASHBOARD WARNINGS CONFIRM THE STEERING AND ADVANCE TRAC FAILURES. ALSO, THE TURN SIGNAL SUSTAIN FAILS, SO USING THE TURN SIGNAL REQUIRES CONSTANT PRESSURE ON THE SIGNAL ARM. ON AVERAGE, THIS PROBLEM HAS RECURRED EVERY 2000 MILES, AT ANY SPEED. TURNING THE CAR OFF AND RESTARTING "FIXES" THE PROBLEM TEMPORARILY UNTIL THE NEXT FAILURE. TWO TRIPS TO THE DEALER FOR EXAMINATIONS HAVE RESULTED IN NO ANSWERS - BOTH TIMES THE RESULTS OF LEAVING THE CAR FOR SEVERAL DAYS HAVE BEEN SHRUGGED SHOULDERS AND "WE COULDN'T DUPLICATE THE PROBLEM, AND THERE IS NO TROUBLE CODE. IT WORKED FINE FOR US." AS IS NOTHING EVER WAS WRONG WITH THE CAR, AND EVEN IF THERE WERE SOMETHING WRONG, THERE IS NO WAY TO REPAIR IT! HOW THE NHTSA AND FORD MOTOR COMPANY CAN ALLOW THESE VEHICLES TO ROAM OUR HIGHWAYS WITH NO RECALL, OR EVEN A TECHNICAL SERVICE BULLETIN, KNOWING THERE IS A CHANCE THE DRIVERS MAY LOSE CONTROL AND CRASH, AS SOME ALREADY HAVE, IS A CRIME AGAINST VEHICLE SAFETY AND AGAINST THE VERY MISSION STATEMENT OF THE NHTSA. I WILL BE COPYING THIS COMPLAINT TO MY ELECTED REPRESENTATIVE IN THE UNITED STATES CONGRESS, WHO IN THE PAST HAS PROVEN TO BE FAR MORE INTERESTED IN MY SAFETY THAN FORD OR THE NHTSA. *JB

Sep 03, 2013

ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM

1 complaint

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE FAILED TO START WITH THE ILLUMINATION OF THE KEY NOT DETECTED WARNING MESSAGE. THE VEHICLE WAS TOWED TO THE CONTACT'S HOME WHERE SHE RECEIVED DIRECTIONS FROM THE DEALER OVER THE PHONE IN HOW TO RESTART THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 20,000. THE CONSUMER STATED THE VEHICLE WAS INSTALLED WITH A NO MECHANICAL KEY START SYSTEM. THE IA KEY FAILED, WHICH LEFT THE CONSUMER STRANDED. THE NO KEY DETECTED ALERT APPEARED ON THE DASHBOARD. THE KEY WAS FIXED. HOWEVER, THE ERROR MESSAGE REMAINED ON THE DASHBOARD. ALSO, THE ENGINE OVERHEATED.

Aug 20, 2013

STEERING,ELECTRICAL SYSTEM,WHEELS

1 complaint

I WAS TRAVELING AT 40 MPH ON A BUSY CITY STREET WHEN ALL OF THE SUDDEN I HEARD A WARNING BING SOUND AND SAW THE POWER STEERING FAULT AND ALL TERRAIN MANAGEMENT FAILURE WARNINGS ON MY INSTRUMENT PANEL. LOST TOTAL ABILITY TO STEER THE VEHICLE AND HAD TO PUT ON EMERGENCY LIGHTS, STOP ON SIDE OF THE ROAD, TURN THE VEHICLE OFF AND ON (HOPING THAT IT WOULD RESET AND RESOLVE THE ISSUE) AND DOING THIS CLEARED THE WARNINGS AND I WAS ABLE TO STEER AGAIN. HOWEVER, TWO DAYS LATER THE PROBLEM HAPPENED AGAIN AFTER STARTING THE VEHICLE IN A PARKING LOT AND BEFORE STARTING TO BACK OUT OF THE PARKING SPACE. ONCE AGAIN TURNING THE VEHICLE OFF AND ON AGAIN RESET THE WARNING AND REGAINED STEERING ABILITY AGAIN. *TR

Aug 06, 2013

STEERING,ELECTRONIC STABILITY CONTROL (ESC),TRACTION CONTROL SYSTEM

1 complaint

I OWN A 2011 FORD EXPLORER, I HAVE HAD NUMEROUS FAILURES TO THE ELECTRONIC POWER STEERING ASSIST. FIRST TIME THIS HAPPENED I WAS ALONG AT ABOUT 65 MPH AND THE STEERING WHEEL LOCKED UP AND THE WARNING LIGHTS STARTED FLASHING "TRACTION CONTROL" "POWER STEERING ASSIST FAILURES" . STEERING WHEEL BECOMES VERY DIFFICULT TO MOVE AND STEER CAR. THIS HAS HAPPENED 1/2 DOZEN TIMES, EACH TIME I SLOWLY STEER THE CAR TO A SAFE STOP TURN OFF THE CAR AND RESTART THE CAR AND ERROR CLEARS OUT. THIS LAST TIME IT OCCURRED AS I WAS TURNING LEFT FROM A LEFT TURN LANE WHEN SUDDENLY IN THE M IDLE OF THE TURN MY POWER STEERING LOCKED UP. FORTUNATELY I WAS TRAVELING AT VERY LOW SPEED, BUT I WAS NOT ABLE TO STEER CAR AND WENT ONTO ONCOMING LANE AGAIN I WAS FORTUNATE NOT TO HIT ANYONE. HOWEVER, THIS TIME THE PROBLEM DID NOT CLEAR ITSELF AND THE CAR IS AT THE LOCAL FORD DEALER FOR 8 DAYS NOW. THE SERVICE MANAGER SAYS ITS A GEAR AND FORD DOES NOT HAVE IT IN STOCK!!! *TR

Dec 17, 2012

ELECTRICAL SYSTEM,EQUIPMENT

1 complaint

2011 FORD EXPLORER. CONSUMER WRITES IN REGARDS TO SYNC MALFUNCTION IN VEHICLE. *SMD THE CONSUMER STATED WHEN THE SYSTEM FAILED, THE SCREEN WENT BLACK AND THE RADIO AND TEMPERATURE CONTROL STOPPED WORKING, AS WELL AS OTHER COMPONENTS. THE SYNC HAS BEEN WORKED ON BY THE DEALERSHIP 13 TIMES.

Dec 03, 2012

VEHICLE SPEED CONTROL,ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

UPON MEDIUM TO HEAVY ACCELERATION, SUCH AS ACCELERATING ONTO A FREEWAY, THE VEHICLE CABIN IS FILLED WITH EXHAUST FUMES FROM THE ENGINE. THIS INJURES THE RESPIRATORY SYSTEM OF THE PASSENGERS. FORD HAS FINALLY ADMITTED THAT THERE IS A PROBLEM, AND THEY ARE WORKING ON A FIX (AFTER MY FAMILY HAS BEEN BREATHING POLLUTED AIR FOR ALMOST 1.5 YEARS). *TR

Nov 21, 2012

Injuries: 4

POWER TRAIN,VISIBILITY,TIRES,ENGINE

1 complaint

PURCHASED THIS VEHICLE FOR MY WIFE A LITTLE OVER A YEAR AGO. AT FIRST EVERYTHING WAS FINE BUT THEN AT ABOUT FOUR MONTHS WE STARTED HAVING ISSUES WITH THE WINDOW NOT ROLLING UP. THE DEALER TOOK CARE OF THAT ISSUE WITH NO PROBLEMS. THEN WE TAKE IT IN FOR THE SCHEDULED MAINTENANCE (OIL CHANGE/TIRE ROTATION) & OUR TIRES HAD INSIDE CUPPING IN WHICH THE DEALER DOES NOTHING ABOUT & STILL HAVE NOT. AT AROUND 22K MILES MY WIFE NOTICES THE VEHICLE STARTING TO JERK WHEN STOPPED OR MOVING. OVER THE PAST 8K MILES THIS GETS WORSE & GETS TO WHERE THE VEHICLE HAS STALLED OUT NUMEROUS TIMES (STILL OR MOVING). I HAVE MADE AN APPOINTMENT WITH THE DEALER TO RESOLVE THIS ISSUE. NOT SURE THE CAUSE YET. *TR

Sep 24, 2012

STEERING,SERVICE BRAKES, HYDRAULIC,FUEL SYSTEM, GASOLINE,STRUCTURE,LATCHES/LOCKS/LINKAGES,SEATS,TRACTION CONTROL SYSTEM

1 complaint

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 5 MPH THE POWER STEERING ASSIST FAILED MESSAGE CAME ON THE INSTRUMENT PANEL, IMMEDIATELY AFTER IT BECAME EXTREMELY DIFFICULT TO MAKE ANY TURNS OR MANEUVER THE STEERING WHEEL. THE CONTACT MENTIONED THAT AFTER POWERING OFF AND RESTARTING, THE VEHICLE WAS PERFORMING AS NORMAL. THE VEHICLE WAS TAKEN TO THE DEALER AND THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO FILED A REPORT AND DID NOT OFFER ANY FURTHER ASSISTANCE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 28,472 AND THE CURRENT MILEAGE WAS 29,600. UPDATED 09/21/12*LJ THE CONSUMER THE ABS AND TRACTION CONTROL FAILURES AND RELATED MESSAGES APPEARED ON THE INSTRUMENT PANEL'S MESSAGE CENTER. THE DEALER FOUND A DIAGNOSTIC CODE FOR THE SPEED SENSORS. THE VEHICLE WAS REPAIRED. UPDATED 09/27/2012 *JS *TR

Aug 13, 2012

ENGINE AND ENGINE COOLING,VEHICLE SPEED CONTROL

1 complaint

WHEN PULLING OUT FROM A STOP SIGN, THE CAR ACCELERATED UP A HILL REACHING A SPEED OF CLOSE TO 90 MPH WITHIN A SHORT DISTANCE. THE CAR WAS DIFFICULT TO CONTROL AND ALMOST COLLIDED WITH AN ONCOMING CAR. ONLY BY PUTTING THE TRANSMISSION INTO NEUTRAL WAS IT POSSIBLE TO SLOW THE CAR DOWN AND PULL OFF THE ROAD. ONCE OFF THE ROAD THE ENGINE CONTINUED TO RUN IN THE 6000 TO 7000 RPM RANGE. IT WAS NOT POSSIBLE TO SLOW DOWN THE ENGINE SPEED. AFTER SHUTTING OFF THE ENGINE AND RESTARTING, THE ENGINE CONTINUED TO RUN AT THESE HIGH RPM. THE CAR WAS TOWED TO A FORD DEALER THAT EVENING (INCIDENT OCCURRED IN THE EVENING). THE NEXT MORNING, I WENT TO THE CAR DEALER AND STARTED THE CAR. IT RAN FINE. FORD DID REPLACE THE THROTTLE BODY. CAR HAS BEEN RUNNING FINE BUT WE ARE CONCERNED IT COULD HAPPEN AGAIN. *TR

Mar 13, 2012

SERVICE BRAKES, HYDRAULIC,AIR BAGS,SEAT BELTS

1 complaint

I PULLED INTO MY DRIVEWAY AT A SLOW RATE OF SPEED, AS I WAS BRAKING THE CAR WAS NOT STOPPING, AS I PRESSED ON THE BRAKE PEDAL IT COLLAPSED ALL THE WAY TO THE FLOOR BUT THE BRAKES DID NOT ENGAGE, JUST BEFORE THE CAR HIT THE GARAGE DOOR WHICH WAS DIRECTLY IN FRONT OF ME THE RIGHT FRONT BRAKE ENGAGED, FULLY, STOPPING THE RIGHT FRONT TIRE ONLY, THE CAR PULLED TO THE RIGHT AND INSTEAD OF HITTING THE GARAGE DOOR IT STRUCK A CONCRETE COLUMN TO THE IMMEDIATE RIGHT OF THE GARAGE DOOR. THE AIR BAGS DID NOT DEPLOY AND THE SEAT BELTS AUTOMATIC LOCKING RETRACTOR DID NOT ENGAGE SO I WAS THROWN FORWARD INTO THE STEERING WHEEL. THE VEHICLE WAS TOWED TO THE DEALERSHIP IT WAS PURCHASED FROM. WE CONTACTED FORD, FILLED OUT AND RETURNED THE PAPERWORK THEY REQUESTED, AFTER ALMOST FOUR MONTHS OF THE VEHICLE SITTING AT THE DEALERSHIP WAITING ON FORD THEY DECIDED THAT THE PROBLEM WAS NOT CAUSED BY A MANUFACTURER'S DEFECT. I AM NOT SURE HOW THEY COULD COME UP WITH THAT ASSUMPTION AS THE VEHICLE WAS NOT IN DRIVABLE CONDITION AND ACCORDING TO THE DEALERSHIP FORD NEVER CHECKED IT. WE HAVE PICTURES SHOWING THE ONE SKID MARK FROM THE RIGHT FRONT TIRE AND NONE FROM THE OTHER THREE TIRES. *TR

Dec 05, 2011

Crash: 1

Injuries: 1

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

1 complaint

MORE LIKE ADAPTIVE 'CURSE' CONTROL. MY 2011 EXPLORER LIMITED 4X4 WITH THE ADAPTIVE CRUISE ALWAYS CATCHES THE REAR OF SEMI TRUCKS IN OTHER LANES, CAUSING IT TO APPLY FULL BRAKES AND PEOPLE BEHIND ME ALMOST CRASH INTO ME. MY 2011 LIMITED IS TOTALLY FACTORY ORIGINAL, NO TOW BARS. HERE IN CALIFORNIA THE SEMI TRUCK SPEED IS 55 WHILE AUTOS CAN GO 65-70MPH (AND IN MOST CASES EVERYONE GOES 80+). SO WHEN I'M GOING ALONG AT 65-70 WITH NO VEHICLES HEAD OF ME IN MY LANE AND THE THING GOES 100% BRAKES I ALMOST CRASH. I ALSO GET THE CRUISE CONTROL TOTALLY DISABLED BECAUSE OF AN ERROR IN THE SYNC MODULES. THE SYNC COMPUTER MODULES CONTROL THE ADAPTIVE CRUISE, STABILITY CONTROL, BACK UP DETECTION SYSTEM, AUTO WIPERS, AUTO PARKING SYSTEM, TRACTION CONTROL, 4X4 SYSTEM, ETC, ETC. I FEAR THAT THE SRS IS ALSO TIED INTO THESE SAME SYNC COMPUTER MODULES. FORD CLAIMS THE SYNC SYSTEM AUTOMATICALLY RESETS/REBOOTS ITSELF EVERY 24 HOURS WHILE THE VEHICLE IS OFF TO AVOID SYSTEM OUTAGES. WHAT HAPPENS MOST OF THE TIME IS THE SYSTEM WILL RUN (EVEN THOUGH THE SCREEN IS OFF) FOR ABOUT A WEEK UNTIL, WHILE DRIVING, THE SYNC COMPUTER CRASHES JUST LIKE HOME COMPUTERS & CELL PHONES DO IF LEFT ON CONTINUOUSLY. WHILE THIS CRASH IS TAKING PLACE THE TOUCH SCREEN FREEZES, MUSIC PLAYING WILL STOP, OR CHANGE VOLUME, OR CHANGE TRACK, OR CHANGE SOURCE; WIPERS WILL STOP WORKING, CRUISE CONTROL WILL SHUT OFF, BACKUP CAMERA SYSTEM GOES DOWN OR SCREEN FREEZES WHILE BACKING UP, 4X4 IS DISABLED, CENTER DISPLAYS WILL GO BLANK. MY 2011 EXPLORER HAS BEEN IN THE FORD SERVICE DEPT FOR SYNC MODULE REPLACEMENT AND REPROGRAMMING 4 TIMES NOW SINCE JAN 2011. STILL NO FIX. *KB

Nov 30, 2011

STEERING,SUSPENSION,SERVICE BRAKES, HYDRAULIC,EQUIPMENT

1 complaint

LETTER FROM RE FEW DEFECTS IN MY 2011 FORD EXPLORER REMAIN AFTER THE DEALERS REPEATED REPAIR ATTEMPTS. THESE ISSUES DISTRACT ME WHILE DRIVING AND IT IS A CONCERN TO MY SAFETY AS WELL *TGW THE CONSUMER STATED THE MAIN ISSUE WAS THE STEERING; THE STEERING WHEEL WAS NOT STRAIGHT AND WHEN DRIVING, THE VEHICLE PULLED IN THE OPPOSITE DIRECTION. THE SHIFT INCREASED WHEN INCREASING SPEED. ALSO, THE A/C UNIT CHANGED TEMPERATURES BY ITSELF. THE BRAKE WARNING LIGHT ILLUMINATED AND THE TOUCH AND SYNC DID NOT WORK. THE CONSUMER BELIEVED THE SOFTWARE NEEDED TO BE UPDATED AS HIS PHONE AND OR MP3 PLAYER KEPT GETTING DISCONNECTED. WHEN USING THE SYNC SERVICE TO REQUEST DIRECTIONS IT KEPT MISINTERPRETING THE COMMANDS, AS WELL AS DISCONNECTING WHEN DOWNLOADING A ROUTE. ON ONE OCCASIONS, THE ENTIRE SYSTEM FAILED AND THE SCREEN WENT BLANK. *JB

Sep 23, 2011

EQUIPMENT,UNKNOWN OR OTHER

1 complaint

I AGREE ABOUT THE MICROPHONE ON THE MY TOUCH SYSTEM. IT PICKS UP WIND NOISE, AIR CONDITIONING/HEATING FAN NOISE & WHEN IT RAINS, DRIVER CAN NOT BE HEARD. IT SEEMS THAT THE ROOF DOES NOT HAVE INSULATION TO ALLOW THE DRIVER TO SPEAK TO THE MICROPHONE WITHOUT SHOUTING. I DID MENTION THIS TO THE FORD SERVICE DEPARTMENT AT OUR LOCAL FORD DEALER AND WAS TOLD THAT THIS IS THE WAY IT COMES FROM THE FACTORY. *KB

Sep 14, 2011

2011 FORD Explorer Problems & Complaints

Complaints by Component

Frequently Asked Questions

How many problems does the 2011 FORD Explorer have?

What are the most common problems with 2011 FORD Explorer?

Where does this 2011 FORD Explorer problem data come from?

Other Years - FORD Explorer

Other FORD Models

Similar Brands