2016 FORD Explorer Problems & Complaints
Real owner complaints and problems reported to the National Highway Traffic Safety Administration (NHTSA). View common issues by component.
2332
Complaints Reported
Complaints by Component
STRUCTURE
463 complaints
The contact owns a 2016 Ford Explorer. The contact was notified of NHTSA Campaign Number: 24V031000 (Structure) and 25V347000 (Structure); however, the parts to do the recall repairs were not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that upon inspection of the A-pillar trims on the driver’s and passenger’s sides, the trim pieces were a bit loose. The manufacturer was made aware of the failure. The failure mileage was unknown.
Dec 15, 2025
The contact owns a 2016 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (STRUCTURE) and 25V347000 (STRUCTURE); however, the parts to do the recall repairs were not yet available. The contact stated that while driving approximately 65-70 MPH, the passenger's side A-pillar trim detached from the vehicle. The local dealer was contacted and confirmed that parts were not available to complete the recall repairs. The vehicle was not repaired. The contact stated that on a separate occasion, the driver's side A-pillar trim became loosened. The local dealer was not contacted after the most recent failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 57,000.
Dec 15, 2025
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign number: 25V347000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that while driving at 65 MPH, the passenger's side B-pillar detached from the vehicle. The local dealer was contacted; however, the vehicle was not repaired. The contact stated that on a separate occasion, the driver's side B-pillar trim became loose. The local dealer was not contacted. The vehicle was not repaired after the most recent failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was 146,721.
Dec 11, 2025
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V347000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that while driving approximately 45 MPH, the passenger’s side trim panel separated from the vehicle. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was not yet repaired. The manufacturer was not made aware of the issue. The contact had experienced the failure listed in the recall. The failure mileage was 91,000.
Dec 11, 2025
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Dec 09, 2025
+ 458 more complaints for this component
STEERING
429 complaints
The contact owns a 2016 Ford Explorer. The contact stated that while driving at approximately 35 MPH, the steering wheel became difficult to turn to the left or to the right. The contact stopped and turned the vehicle off and restarted the vehicle, and the power steering functionality returned. The contact stated that the failure had occurred twice and during the second failure the check engine warning light illuminated. The contact had not taken the vehicle to a local dealer or an independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 79,000.
Oct 20, 2025
The car had ongoing issues with a warning sensor that stated Steering Fault - Service Now. There was also a clinking noise when driving straight and then turning right. Took car to dealer repair show and they ran a diagnosis report (I assume they did). It was reported that it was an internal fault with strut bearings and installed a bracket that was suppose to remedy the issue. Since then I would get the Steering Fault warning but it would happen and then not show up for several months. Recently 8/2025 the error message showed up again while driving about 30 mph. At that time my steering locked. I turned off the car and started it again and it seemed fine. My husband and I test drove it short distances and there was no issues. Then I drove it down the road that I was on when it happened a couple days earlier (since it was a hilly road I thought it caused something to come loose thence the warning). I stopped at a vegetable stand and when restarting the car I received the steering warning again. I turned the car off and then on and proceeded down the road. Within a few feet the warning flashed on and also warning that said Service Advance Trac and Hill Start Assist Not Available and Terrain warnings. I took the vehicle back to the dealership again 9/4/2025 at this time I had 93,300 miles on it. They ran a diagnosis report on it and said I needed to replace the Steering Rack at a cost of over $4000.00 plus fees for alignment, etc. FIRST OF ALL - I think this should have been diagnosed when the car was in for steering issues in 2022 - Especially since Ford was aware of issue with the Steering Rack and it is a serious safety issue. SECOND - There should have been a safety recall for Steering Racks on these vehicles. I'm only fortunate that this did not happed when driving on a highway higher speed.
Sep 09, 2025
Dear NHTSA, I am submitting a formal safety complaint regarding my 2016 Ford Explorer (VIN: [XXX] .) Build Date: (08/15.), Mileage (115,262.). My vehicle has experienced a steering rack failure, which poses a serious risk of loss of steering control. I am aware of multiple recalls (such as 20v-675 / Ford 20S62 and 21V-537 / Ford 21S32) Addressing rear suspension toe link fractures in 2016 ford explorers. These recalls cover vehicles built in the same timeframe as mine, but my VIN is not included. This exclusion is concerning, as both the steering rack and suspension defect involve loss of steering control and directly impact driver and passenger safety. I respectfully request that NHTSA investigate: 1. Why certain VIN's, including mine, were excluded despite being manufactured in the recall window. 2. Whether steering rack failures in the 2016 ford explorer should also be subject to an official safety recall. Thank you for your attention to this urgent safety matter. I look forward to hearing from somebody. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Aug 26, 2025
The contact owns a 2016 Ford Explorer. The contact stated that the vehicle lost power steering assist functionality, and the steering wheel was stuck while attempting to turn the steering wheel to the left or the right. There were no warning lights illuminated. The contact spoke with the dealer and was informed that the power steering assist had failed and needed to be repaired. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 97,000.
Aug 13, 2025
The contact owns a 2016 Ford Explorer. The contact stated that while in reverse(R), the vehicle failed to turn to the left or right, and the steering wheel was stiff. The contact stated that when the vehicle was shifted into drive(D) and pulling into a parking spot, the steering wheel was stiff. There was no warning light illuminated. The contact stated that the vehicle was turned off and restarted without the failure recurring. The vehicle was taken to a dealer for maintenance on the brakes, and the vehicle was diagnosed, and it was determined that the steering rack assembly needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was approximately 93,500.
Aug 04, 2025
+ 424 more complaints for this component
UNKNOWN OR OTHER
272 complaints
Recall ford # 21S22 roof rack cap. I called ford and reported that the roof rack cap has broken off. They stated that recall for my vehicle has been completed and closed. If the issue is still happening after the recall has been established even if it has been repaired, why is it still not covered under the recall. The repairs made to correct it were obviously not adequate.
Dec 17, 2025
When driving my Explorer feels like the gear is stuck making the vehicle jerk. Very loud at start up from fan. I have taken it to get the code read, I think it stated transmission needed to get checked.
Nov 30, 2025
The windshield trim on my car is missing. There is a recall on this but there is no remedy yet. With this not being fixed it is causing a safety issue with our car as well as allowing our car to flood inside when it rains. I have contacted Ford and they told me unfortunately there was nothing they could do at this time.
Nov 19, 2025
When accelerating more rapidly (like getting on interstate), a burning smell will enter the cabin. It is not noticed at low speeds, nor when acceleration to high speeds happens gradually. The smell is strong and lingers for about one minute.
Oct 18, 2025
The rear camera is compromised because water gets inside and is blocking the view of the camera. You are unable to use the rear backup camera because the view is completely blocked or blurred by the water or moisture that is able to get in.
Oct 14, 2025
+ 267 more complaints for this component
ENGINE
205 complaints
Coolant intrusion in the cylinder walls
Oct 01, 2025
Torque converter issue causes shuddered, can cause driver to unexpectedly adjust speed rapidly.
Sep 29, 2025
Took the family SUV in for a standard oil change and 100k service to Ford dealership. Upon performing a coolant flush, the water pump began leaking. It was found that the internal water pump was leaking and needed to be replaced along with the primary timing chain and tensioner items. There were no warning lamps or indicators to let us know this was an issue. The dealer service center replaced the internal water pump, refilled system and test drove. It was re inspected and leak has been corrected. However, this cost us $4, 366.80 for an issue Ford knows is a reoccurring issue in this model of SUV and a huge hazard for families.
May 27, 2025
The contact owns a 2016 Ford Explorer. The contact stated that the vehicle was idling rough while shifted into drive or reverse. The contact stated that the vehicle operated normally while moving. There was no warning light illuminated. The local dealer was not contacted; however, the vehicle was not diagnosed. The vehicle was not repaired. The contact referenced Technical Service Bulletin: 20-2271; as a possible cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 111,000.
May 12, 2025
Engine stalls out when accelerating, coolant is leaking into the motor. Got it checked out my mechanic, needs new engine due to improper manufacturing issue
Apr 06, 2025
+ 200 more complaints for this component
POWER TRAIN
125 complaints
The contact owns a 2016 Ford Explorer. The contact stated that while driving at various speeds, the vehicle vibrated, and there was an abnormal knocking sound coming from the transmission. In addition, the vehicle drove roughly while the transmission was downshifting, and the vehicle failed to accelerate as needed. No warning lights were illuminated. The vehicle was taken to the dealer, where it was diagnosed with torque converter failure. The contact was informed that the torque converter needed to be replaced, or the transmission could be replaced. The vehicle remained at the dealer unrepaired. The manufacturer was made aware of the failure and referred contact to the NHSTA Hotline for assistance. Upon further investigation, the contact related the failure to the Technical Service Bulletin: 20B27. The failure mileage was approximately 100,000.
Aug 18, 2025
Transmission slips in and out of gear while driving causing loss of power. Many complaints online about this same issue from others.
Jun 21, 2025
The contact owns a 2016 Ford Explorer. The contact stated that the vehicle experienced rough idles while his wife was driving the vehicle. The vehicle was taken to the dealer, where it was diagnosed that the torque converter had failed and needed to be replaced. The vehicle was not repaired. The vehicle was then taken to an independent mechanic, where it was confirmed that the torque converter needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 92,000.
Jun 12, 2025
The contact owns a 2016 Ford Explorer. The contact stated while driving 35 MPH, the vehicle shuddered abnormally with the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the transfer case had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 135,401.
Jun 11, 2025
The contact owns a 2016 Ford Explorer. The contact stated that while attempting to reverse, the accelerator pedal was depressed; however, the vehicle hesitated while responding. The contact stated that after several attempts to depress the accelerator pedal, the vehicle responded as intended. The contact stated that a dealer was not contacted. The vehicle was not taken to be diagnosed or repaired. The manufacturer was notified of the failure but offered no assistance. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The contact related the failure to NHTSA Campaign Number: 20V692000 (POWER TRAIN); however, the VIN was not included in the recall. The approximate failure mileage was 168,000.
Apr 09, 2025
+ 120 more complaints for this component
ENGINE AND ENGINE COOLING
86 complaints
The contact owns a 2016 Ford Explorer. The contact stated that while operating the vehicle, the engine overheated, and the temperature gauge had increased to high with the check engine warning light remaining illuminated. The vehicle was taken to the local dealer who diagnosed that the water pump was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer and local dealer were notified of the failure, but no assistance was provided. The failure mileage was 116,000.
Jul 02, 2025
The contact owns a 2016 Ford Explorer. The contact stated that while her husband was driving at an undisclosed speed, the vehicle stalled after coming from a stop. No warning light was illuminated. The vehicle was able to be restarted. The contact stated that the water pump had previously been replaced twice, but the failure persisted. The vehicle was taken to an independent mechanic, who determined that there was coolant intrusion in engine and the water pump needed to be replaced for the third time. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 177,000.
Jun 24, 2025
The contact owns a 2016 Ford Explorer. The contact stated while driving approximately 40 MPH, the accelerator pedal was depressed, and there were exhaust fumes entering the cabin of the vehicle. The contact stated that the exhaust odor entered the vehicle while depressing the accelerator pedal and was constant. The contact stated there was no warning light illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the failure was related to Technical Service Bulletin Number: 17-0044; and the recommended that the repair be performed. The contact was advised that the vehicle was no longer under warranty. The vehicle was not yet repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 100,000.
May 01, 2025
The contact owns a 2016 Ford Explorer. The contact stated while driving 68 MPH, the vehicle shut off unintendedly. After the failure, the engine warning light illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 16V925000 (Engine and Engine Cooling); however, the VIN was not included. The vehicle was taken to an independent mechanic where it was determined there was water in the engine oil. The local dealer was contacted and confirmed that there was no recall on the VIN related to the failure. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 164,000.
Apr 28, 2025
The contact owns a 2016 Ford Explorer. The contact stated that while his sister was driving 55-60 MPH, the engine started to overheat, and there was fluid leaking from the vehicle. The contact stated that there was oil in the coolant overflow tank. There were no warning lights illuminated. The vehicle was taken to an independent mechanic who determined that the engine needed to be replaced. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 120,000.
Apr 18, 2025
+ 81 more complaints for this component
AIR BAGS
59 complaints
air bag light illumination on occasion, ford confirmed and suggested $1000 repair. seems like a safety issue that is a manufacturer defect. vehicle has been maintained and rear seat rarely used.
Aug 22, 2025
The rear seats in my 2016 ford explorer platinum have a know air bag issue that ford said is not a safety issue when addressed. It is a know issue by ford and they refuse to fix it because it is not under recall. The air bag light illuminate due to a worn or damaged connection to the rear inflatable seat belt connector which in turn will cause the rear airbags to not deploy during an accident.
Jun 02, 2025
As I was driving the vehicle the airbags deployed without a collision. I was in the car with my wife and 2 month old son. Had we been going full speed it could've been much worse than it was. The vehicle is available for inspection upon request. The car has not been inspected in any way. The insurance company is currently attempting to deny the claim based on pictures alone. There were no warning lamps prior to the airbag deployment regarding the airbags. We did not hit another car. I was able to stop the car in the middle of the onramp.
Dec 03, 2024
The passenger side knee airbag went off in an accident causing my dad to have severe lacerations to both legs and a sprained ankle. Those were his only injuries from the accident. All caused by one airbag. There is a good chance he will need a skin graft on one of his legs. The emt and firefighters all said that they have never seen an airbag down there and loon like that. What it did to his legs is horrible. And should have never of happened.
Oct 03, 2024
Air Bag light on. Per Dealer service center diagnostics, driver side air bag module FB5Z*78043B13*AA defective. Module replaced, however air bag light on persists. Additional diagnostic determined that air bag clockspring component defective.
Sep 28, 2024
+ 54 more complaints for this component
FUEL/PROPULSION SYSTEM
41 complaints
Gas filler neck is loose, making it difficult to fill the gas tank without spillage. I don't recall how long this has been an issue, but it has been a problem for multiple years. There have been no incidents that preceded this problem.
Dec 07, 2025
On June 14, we drove our 2016 Ford Explorer from Tallahassee, FL to Boone, NC without issue. However, on [XXX], upon starting the vehicle, we noticed a gasoline smell. Concerned for our safety, we checked the car before leaving the neighborhood and discovered fuel pouring from the front. We parked the vehicle in a safe location and coordinated a tow to the local Ford dealership and were informed our fuel line had ruptured. The vehicle had 41,000 miles at the time of the incident. We were not given a clear explanation for the fuel line rupture, leaving us apprehensive about the safety and reliability of Ford vehicles. The ordeal cost $4,000 in repairs, and the service experience made us feel taken advantage of after we were routinely asked if we were local. Our Ford mechanic in Tallahassee later mentioned that labor charged by the Boone dealership seemed excessive. Additionally, they refused to replace the gasoline-covered cabin air filter and engine cover, raising further concerns about the service provided. The rupture of the fuel line posed a severe safety risk as it could have led to a fire or explosion, endangering the lives of the occupants and others nearby. The problem has not been reproduced but was confirmed by the local Ford dealership. No inspections have been conducted by the manufacturer, police, or insurance representatives to our knowledge. There were no warning lamps, messages, or other symptoms of the problem prior to the failure. Our gas tank was nearly full the morning of June 17, and it was empty when we picked it up from the Ford dealership after repairs were completed. Given the serious nature of the fuel line failure, the potential risks involved, and the financial burden of the repairs, we believe this issue warrants a recall investigation to prevent future incidents and to ensure the safety of Ford customers, especially given the multiple recalls already issued and the shared “significant safety concern” shared by the NHTSA on this. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Jun 24, 2024
My purge valve was stuck open and had strong fuel vapors leaking inside of the car cabin. I became lightheaded and went to the ER. This was before the check engine light came on. It was very concerning.
Sep 27, 2022
Exhaust leaks into cab under moderate to heavy acceleration with windows closed it is even worse when accelerating with the windows open
Oct 03, 2021
DURING ACCELERATION CAR SMELLS LIKE ROTTEN EGGS ALL WINDOWS NEED TO BE OPEN TO VENT CAR AND ALL PASSENGERS GET NAUSEOUS. DEALER TRIED TWICE TO FIX PROBLEM BUT WITH NO SUCCESS.ITS GETTING IMPOSSIBLE TO DRIVE THE CAR ON HIGHWAY.FORD NEEDS TO DO SOMETHING ASAP.
Jan 24, 2021
+ 36 more complaints for this component
WHEELS
35 complaints
Rear toe link (driver side) just purchased the car from a Police department and i was not aware of the recall. 10/8/24 i made an appointment for other service and was informant by Elk river MN ford dealer and recall is scheduled to be preformed 10/17/24. [XXX] at [XXX] when turning left at approximately 30mph (2 lane country roads) the vehicle became uncontrollable mid turn. vehicle did not hit anything. After stopping found driver rear toe link had broken at the weld joint on the knuckle side. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Oct 11, 2024
Vehicle started to feel heavy, and vibrate harder through the gas pedal and steering wheel. I took it to my local auto shop and the wheel bearing needs replaced.
Aug 03, 2021
MY 2016 FORD EXPLORER JUST TURNED 36,000 MILES AND ALL FOUR OF THE HANKOOK VENTUS S1 NOBLE 2 TIRES THAT CAME ON CAR HAVE PREMATURE WEAR, WITH 3/32ND OF AN INCH REMAINING ON THE TREAD. THERE HAVE BEEN NUMEROUS COMPLAINTS ABOUT PREMATURE TREAD WEAR WITH THIS TIRE AND FORD WILL NOT DO ANYTHING ABOUT IT. I WAS TOLD BY FORD MOTOR CUSTOMER SERVICE THAT BECAUSE MY CAR HAS TURNED 36,00 MILES THERE IS NO WARRANTY COVERAGE OR OTHER RECOURSE THAT I CAN TAKE. THIS IS A SAFETY ISSUE. THE SERVICE MANAGER AT MY LOCAL FORD DEALER, CHATHAM FORD, WHERE I PURCHASED THE VEHICLE ALSO TOLD ME THAT THIS PARTICULAR TIRE SHOULD NOT BE USED ON AN EXPLORER. YET MY DEALER ALSO SAID THAT THEY CANNOT DO ANYTHING TO HELP ME. THERE APPEARS TO BE A DEFECT WITH THIS TIRE AND THERE SHOULD BE A RECALL.
Sep 03, 2019
PREMATURE TIRE WEAR CAUSING INADEQUATE TRACTION IN ADVERSE WEATHER CONDITIONS
Jul 15, 2019
2016 EXPLORER LIMITED PURCHASED NEW, CURRENTLY HAS 32,000 MILES ON IT AND TIRES ARE SHREDDING AND NEED TO BE REPLACED, WELL BELOW THE RATING OF 50,000 MILES. HANKOOK TIRES
Apr 15, 2019
+ 30 more complaints for this component
ELECTRICAL SYSTEM
34 complaints
Intermittently, the vehicle's backup camera displays a blank (black) image when the vehicle is placed in reverse. The issue resolves its self by turning the vehicle off and back on.
Sep 10, 2025
Odometer Fraud. The contact purchased a 2016 Ford Explorer. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 150,831 and at the time of registration, it was discovered that the mileage was previously documented as 161,000.
Jul 10, 2025
See attached document for complaint.
Jun 11, 2025
The contact owns a 2016 Ford Explorer. The contact stated while driving at an undisclosed speed, the keypad detached and flew off the driver’s side door. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The dealer was made aware of the failure. The contact referenced an unknown recall; however, the VIN was not included in the recall. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 104,000.
Jun 09, 2025
Odometer Fraud. The contact purchased a 2016 Ford Explorer. The contact stated that while attempting to apply for a loan, it was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was approximately 93,000 and at the time of registration, it was discovered that the mileage was approximately 244,000.
May 15, 2025
+ 29 more complaints for this component
UNKNOWN OR OTHER,ENGINE
32 complaints
Good Morning, I’m reaching out in regards to my 2016 Ford Explorer. I’ve been trying to get the necessary recall repairs completed, but unfortunately, I’ve been unable to locate the required pillars for the repairs. I recently brought my vehicle back to the dealership, but was told that no work can be done until both parts are available. I was also advised to try sourcing one of the parts from another Ford dealership on my own, which I’ve had no luck with. To be honest, I’m feeling very overwhelmed. I purchased this vehicle used, back in September 2025, and since then, it has been one issue after another. I’ve already invested more into mechanical repairs than what I currently owe on the vehicle. I’m a [XXX], and this vehicle is our only mode of transportation. I’m growing increasingly concerned for our safety, especially knowing that the recall parts are critical and things could start to fall apart — literally — if they’re not addressed soon. With that said, I would greatly appreciate your help in exploring any other options available through Ford or the dealership. Some specific questions I have are: Is there any way for the dealership to help source the necessary parts through other Ford networks or escalate this to Ford corporate? Can you assist with a temporary vehicle solution while waiting on the parts (loaner or rental)? Would there be any way to explore trading in or transitioning into another vehicle, even with the current issues and financial position I’m in? I understand that supply issues happen, but I’m just trying to keep my kids and myself safe, and right now I’m feeling stuck. I would extremely appreciate any help or direction you can offer. Please feel free to call or email me directly. I look forward to hearing from you. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Jul 21, 2025
I’ve had it twice be an issue where the engine didn’t run quite right. The first time I took it to the mechanic it was determined the timing chain was bad and they also said this is a well known issue with the ecoboost engines in these explorers. Only about a year later after replacing that and the water pump I went to start the explorer and it wouldn’t start. Took it to the mechanic again and they found that the timing chain, again, had failed and this time it also caused damage to a piston rod. They said they were surprised it wasn’t catastrophic damage to the engine because of this. I’ve now had to spend literally thousands of dollars on this vehicle for timing chain related issues alone in just over 3 years of owning it. Searching online finds unending reports of similar issues to this as well as massive issues with the turbos and the cam phasers that also commonly are causing catastrophic engine failures despite routine preventative maintenance being performed. And the a pillar recall issue. I had it inspected December of 2024 and determined it needed them replaced. I was not given a time frame when that would be completed. I got a call over a month ago from the dealer saying to call them to schedule a repair. I did so and then was told that while I was on the list they still are unable to get any parts from Ford to repair this mandated recall and also cannot get a timeline on when said parts would be available. I’m almost six months past them saying it’s been ordered and still no idea when it’ll be repaired. And now a second recall was just announced for the b post coverings and I’m sure this will be just as bad. As many issues as this car is having I think Ford should have to pay for a lot more recalls than they have so far. I also had to have two other recalls fixed that the selling dealer didn’t address before selling to me.
May 31, 2025
2016 Ford Explorer. Wife was sitting in running vehicle, in line waiting to pick up our kids from school. Warning lights came on and engine sputtered out. Was checked by personal mechanic said coolant was empty but no leaks on ground at school. Said signs of past leakage. I filled with antifreeze and it ran fine with no visible leaks. @ months later i noticed reservoir low. Brought to ford for the luggage rack recall and had them check coolant issue and do oil change. Water Pump. We had only owned the car for six months. How many thousands of people need to have issues with the water pump failing before we get any help. For god sakes its becoming a meme. Ok another couple thousand after i just had the water pump on my lacrosse replaced. Kids can go without food again. At least we weren't traveling down the turnpike at 70 mph when it happened.
Feb 14, 2023
Unknown system or components, smells like propane or exhaust odors inside the cab. Mostly when driving slow or at a full stop. It is a police interceptor suv with 65k miles. No warning lights or other symptoms appeared prior to odor. Odor gives me a headache/nausea.
Nov 10, 2022
My wife has been reporting experiencing nausea, dizziness, sleepiness and headaches during and after her drive home from work throughout October/November 2021and into December 2021. Our vehicle was involved in a high speed collision on December 24, 2021 while traveling EB on I-90 at approximately MP 101. I was driving at the time. It was at about 3:29pm. I couldn't quite recall what had happened and I was disoriented and confused for some time after the collision though I hadn't hit my head. Everyone else in the car had fallen asleep despite being well rested and it being the middle of the afternoon. My symptoms and condition were the same as oxygen deprivation. I believe exhaust has been getting into the cabin of our vehicle and causing my wife's symptoms and caused the accident. The vehicle is totalled.
Jan 27, 2022
+ 27 more complaints for this component
SUSPENSION
31 complaints
The contact owns a 2016 Ford Explorer. The contact stated that while his grandmother was driving and decelerating, the rear passenger’s side suspension suddenly failed, rendering the vehicle undrivable. The vehicle was towed to the local dealer, who determined that the rear passenger’s side tow link had failed and that both the rear passenger’s side and driver’s side tow links needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, and the contact was informed that the vehicle was previously serviced under NHTSA Campaign Number: 21V537000 (SUSPENSION). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 143,000.
Oct 30, 2025
I brought my vehicle in for a recall that replaced the rear toe links. The factory adjustable toe link was replaced with a solid non-adjustable toe link. This dealer stated there is no way to adjust the toe. My vehicle feels like the rear is “dancing” when I hit most road imperfections. In the rain, it gets significantly worse. I will be taking my vehicle to an independent shop, but the recall work has unintentionally created a dangerous condition due to no longer being able to align the rear of the vehicle. The recall done was Safety Recall 20S62. I feel at a minimum, Ford needs to cover the costs incurred by owners paying to have the new toe links removed and replaced with aftermarket adjustable toe links, as well as paying for the alignment. I have reached out to both the dealer and Ford. The dealer stated they performed the recall as described by Ford. However, the recall states to align the rear as the last step, but the dealer states the toe link is a single piece, which is therefore not adjustable. Ford customer service told me there is no updates to the recall at this time and to bring my concerns to my local Ford dealer. Thanks.
Jul 26, 2024
The contact owns a 2016 Ford Explorer. The contact stated while driving 20 MPH in the snow, the vehicle started fishtailing. The contact was able to continue driving at slow speeds. The vehicle was taken to an independent mechanic for an alignment; however, the mechanic informed the contact that the rear suspension toe links had failed and needed to be replaced. The mechanic determined that the failure was related to NHTSA Campaign Number: 21V537000 (Suspension) and referred the contact to the dealer for assistance. The contact stated that the failure recurred while driving in the rain. The contact veered to the side of the road. The contact was able to continue driving after the rain stopped. The contact stated that the failure had been recurring increasingly while driving over potholes. The vehicle was taken to the dealer, where the contact was informed that the vehicle was not covered under the recall because the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was unknown.
Jun 24, 2024
The contact owns a 2016 Ford Explorer. The contact stated that the vehicle was taken to an independent mechanic for service, and the contact was made aware of a failure with the rear upper control arms. The contact stated that both control arms displayed abnormal movements, and the suspension could not be properly aligned. No warning lights were illuminated. After investigating the failure, the independent mechanic related the failure to NHTSA Campaign Number: 21V537000 (Suspension) however, the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 116,000.
May 08, 2024
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 21V537000 (Suspension). The contact stated that on several occasions while driving at various speeds and making a left or right turn, the wheels continued to turn. The vehicle was taken to a dealer where the contact was informed that the electric steering rack and pinion needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 70,000.
Mar 22, 2024
+ 26 more complaints for this component
VEHICLE SPEED CONTROL
28 complaints
I was stopped at a major intersection (very busy) at a red light when my car quit. I tried to restart the car but nothing happened. I was at the bottom of a hill, which has a turn not long before you reach this intersection, the speed limit is 45 mph but its normal for cars to average 50-60 mph. I put my flashers on and called AAA. Cars were piling up behind me trying to get in the other lane, horns were blowing, it was a dangerous situation! I had to remain in my car as it was not safe to get out and try to get to the side of the road. After about 15 minutes I tried to start the car again, I was able to get it going and remove myself from an unsafe situation. The car was not running properly, it was "bucking" and trying to stall, fortunately I was able to get to a safe area to pull over and get it towed. The above was written by my wife, I was not there. I am a retired Staff Engineer for a major OE and have authored many Recalls over my 35 years. This issue is a dangerous pattern failure that Ford issued a Stop Sale for. The failed part, the ETB located on the Throttle body is used on multible models with exactly the same failure. How this hasn't been recalled is amazing. This is a known safety problem, pattern failure of the ETB across madels lines that use that engine (3.5). My car is safe now but what about the ones that will failure tomorrow?
Nov 17, 2023
Sudden deceleration due to P2112 code, electronic throttle body stuck closed.
Oct 20, 2023
On Wednesday, November 2, 2022, at about 4:00 pm I proceeded to parallel park my vehicle and as I put my foot on the gas pedal the car took off uncontrollably at a very high speed, I tried to control the car but before I could stop it, I crashed and hit a tree. My vehicle was severely damaged. The vehicle was taken to the Dealer for inspection, and I was told there was nothing wrong. I know what happened and there is something wrong with this vehicle. I am glad that the tree was there because if not I believe I would have ended inside the house that was behind the tree and could have injured someone. My vehicle is at the body shop now, but I don't think I will drive it anymore, I don't feel safe in it.
Nov 09, 2022
The contact's girlfriend owns a 2016 Ford Explorer. The contact stated after placing groceries inside the vehicle, the contact heard a chime as the liftgate independently started closing, almost striking him on the head. The contact also stated while driving at various speeds, the vehicle would stall or surge upon depression of the accelerator pedal, with the service engine warning light illuminated. The contact also mentioned that the side-view mirrors would independently adjust while driving at various speeds. The contact stated that he manually adjusted the mirrors to correct his driving visibility. The manufacturer was notified of the failure. The contact was informed that the VIN was not under recall. The contact was then transferred to NHTSA for assistance. The vehicle was not repaired. The failure mileage was approximately 57,000.
Jun 07, 2021
WE ARE DRIVING BACK FROM ZION NATIONAL PARK THEN IN THE FREEWAY SUDDENLY I LOST POWER LUCKILY IT WAS ON A DOWN HILL. I WENT ON THE SIDE OF THE ROAD THEN THEN COUPLE I STARTED RIGHT BACK. NOW AM AFRAID DRIVING IT FAR AWAY. FROM TIME TO TIME WHEN UPHILL IT JERK A BIT AND IT FEELS LIKE LOOSING POWER.
Jan 27, 2021
+ 23 more complaints for this component
POWER TRAIN,ENGINE
21 complaints
The explorer started having issues with the heater not working when stopped. After some research it recommended that we check the coolant level. The coolant was low. Then we refilled it and then it happened again 3 weeks later and the coolant was low. This made us believe there was a coolant leak. After removing the bottom cover under the car it was saturated with coolant with drops coming from various areas on the passenger side. We took it to a mechanic and then transferred to a dealer and both confirmed it was the water pump. Ford negligently designed the water pump within the engine with the timing chain. If enough of the coolant mixes with oil it will cause the engine to seize and the car to shut off. I have two little kids that are in the car with me. This negligent placement can lead to cars seizing in unsafe areas. It was confirmed by a private mechanic and a ford dealer and there were no warning lights. Other than the heat not functioning properly there we no other signs or lights of water pump failure.
Feb 22, 2024
The contact owns a 2016 Ford Explorer. The contact stated that while at a complete stop, the vehicle was shifted into drive(D) and the brake pedal was released; however, the vehicle started shuddering and jerking significantly. Additionally, the contact stated that the vehicle hesitated to shift into the intended gear while driving. The contact stated that the failure had been recurring while driving. The check engine and the power train warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was not repaired. The contact stated that the insurance company later informed her of Ford Campaign Number: 20B27, which she related to the failure. The dealer was notified of the failure. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under the Campaign. The manufacturer referred the contact to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 121,000.
Sep 29, 2023
The contact owns a 2016 Ford Explorer. The contact stated that while attempting to shift the gear shifter into park(P), the transmission failed to shift as needed. The contact stated that the transmission would only shift into reverse(R). An independent mechanic flipped an unknown switch, and the contact was able to drive her vehicle to her residence; however, when the contact attempted to shift the transmission into park(P), the transmission would only shift into reverse(R). The contact's son flipped the switch, and the contact was able to shift the transmission into park(P). Additionally, the check engine warning light illuminated intermittently. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and referred the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 152,000.
Jun 12, 2023
I was driving my vehicle only a month after getting oil change and service. I was confident my vehicle was in good condition as it had passed the inspection. I suddenly noticed the temperature needle was rising. I immediately pulled over and asked for help and was told i needed water. My water pump was not working.
May 09, 2023
Water pump failed at 80,000 miles and cause the car to stall mid intersection putting out life at risk. This is a known issue that should be recalled . Not to mention the repair is $4,000-$6,000 mostly labor to fix. Whole motor has to be taken out to replace the water pump.
Dec 28, 2022
+ 16 more complaints for this component
SEATS
20 complaints
The heated seats went out. Took to mechanic shop, the wires burned out and also melted the fuse box. All that has to be replaced. Ford Dealership only sells the whole wiring harness which is over $1,000. With the wires burning out and then melting fuse box, lucky my car didn't burn.
Jan 25, 2024
The contact owns a 2016 Ford Explorer. The contact stated that after noticing that the seat heaters were inoperable, he saw that the heated seat module connector had melted. The contact also stated that the front passenger’s side seat controls were inoperable. No warning lights were illuminated. The vehicle had not yet been taken to an independent mechanic or a local dealer to be diagnosed or repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The approximate failure mileage was 120,000.
Apr 14, 2023
The contact owns a 2016 Ford Explorer. The contact stated that the third -row passenger’s side seat was not properly secured to the floor of the vehicle. The contact indicated that an unknown part used to attach the seat to the floor had fractured and the seat was no longer secured to the floor. The vehicle was taken to the local dealer who indicated that the unknown part needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 50,000.
Jan 12, 2023
Vehicle right passenger area receives no heat, either from front heat vent nor does the seat heater function. Dealer replaced seat heat mechanism(s) that required software update. Update failed to resolve the problem. Outside temp is now -13°F. Dealer states they are awaiting dealer engineers to determine how to repair the problem.
Dec 10, 2022
The contact owns a 2016 Ford Explorer. The contact stated that while driving at an undisclosed speed, the driver's side front seat inadvertently moved back and forth. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA. The failure mileage was approximately 105,000.
Jun 29, 2022
+ 15 more complaints for this component
SEAT BELTS
18 complaints
SECOND ROW PASSENGER SEATBELT RECIEVER IS BROKEN AND PART HAS NOT BEEN AVAILABLE FOR OVER 2 YEARS. PART # DB5ZZ786004EB. THIS IS A MAJOR SAFETY ISSUE AND FORD HAS NO IDEA WHEN THEY WILL RESUME MAKING THIS PART. ALSO, PARTS FOR PILLLAR RECALL ARE NOT AVAILABLE. PILLAR FALLS APART, CAUSING DAMAGE TO MOULDING AND NOW WATER HAS ENTERED AND DAMAGED THE VEHICLE. FORD HAS NO ACCOUNTABILITY? PEOPLE ARE FIXING THIS ISSUE THEMSELVES ( LIKE WE DID WITH OTHER SIDE), AND NOW AFTER MARKET PARTS HAVE BECOME SCARCE TOO.
Sep 13, 2024
The contact owns a 2016 Ford Explorer. The contact stated that while the vehicle was started, the air bag warning light illuminated. The vehicle was taken to a dealer where it was diagnosed that the seat belt retractor was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 106,000.
May 16, 2024
Middle row, passenger side seat belt buckle is broken & will not latch. This is where my 9yr old sits & there is no reason or cause for this to break. My vehicle has the inflatable airbag seatbelts on this row.
Oct 27, 2023
The seat belt buckle for the second row passenger-side broke, making it impossible for the seat belt buckle to lock. Ford said the part was back ordered. When the part arrived and the car was being fixed, we received a call from the service manager advising the second row driver-side buckle broke as well. This seems to be a recurring issue.
Jul 11, 2023
The contact owns a 2016 Ford Explorer. The contact stated that the middle row passenger’s side seat belt malfunctioned and could no longer be retracted. The vehicle was taken to the local mechanic who diagnosed that the seat belt assembly needed to be replaced. The vehicle was not yet repaired. The local dealer and manufacturer were notified of the failure and stated that the part was on backorder. The failure mileage was 85,000.
Mar 02, 2023
+ 13 more complaints for this component
VISIBILITY
18 complaints
The contact owns a 2016 Ford Explorer. The contact stated while driving at an undisclosed speed, the contact became aware that the sunroof had started to detach and had sunken into the interior of the vehicle, creating an opening that allowed water to leak into the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the sunroof motor. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 116,000.
May 08, 2024
While driving on the highway, windshield trim flew off (2 different times, passenger and driver side). It scared me at first when it started to come loose because it flapped around and I wasn’t really sure what was going on. And can’t pull over or slow down on highway. When it broke off, it flew up in the air and almost hit another car. I was distracted trying to see what it was and where it landed behind me. So definitely a safety concern. Total repair cost $650
Dec 26, 2023
The contact owns a 2016 Ford Explorer. The contact stated while driving 70 MPH, the front windshield trim separated and detached from the vehicle. The dealer was contacted, and the dealer stated that the warranty did not cover the trim replacement. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 82,300.
Mar 15, 2023
I know it was a Friday in April 2021 not sure what Friday. I was driving down I95 and noticed weather stripping from right side of windshield flapping and hitting the side of the car. Suddenly a piece of plastic flew off the car I am not sure but I do think it hit a vehicle behind me. I immediately pulled over and slowly proceeded on the shoulder incase the other car stopped. No car stopped so I proceeded home. I took the car to have vehicle fixed. Several Ford dealers and three auto repair shops stated "this happens all the time". What was really upsetting was the cost to replace the part. even more upsetting was no one wanted to fix it, advised that in Florida if you end up with a crack or chip in window, insurance will replace windshield. This part usually needs replaced when replacing windshield so told to just wait to you have to replace windshield. It doesn't hurt or cause leaks. But it looks crappy. now I see Ford Explorers all the time missing the trim piece. My vehicle almost all of the weather stripping has rotted away as well. I did just what everyone advised wait to I have windshield damage. BTW I am always needing to clean the windshield manually as my windshield washer has never worked properly from day one. Now it doesn't work at all. Fast forward just over a year later It was late May or early June 2022. I am again on I95 returning home after retrieving both of my parents death certificates (they both died 12 days apart) I again hear banging noise this time on left side of car. Luckily it was about the time I was about to my exit. I pull over and find the left side of window trim stuck in the left rear wheel well. and was flapping against the car. I was able to pry it loose and thankfully it didn't fling with force and hit someone or another vehicle. If Ford knows this happens all the time why do they not recall it. Heck I am tired of my transfer case constantly needing repaired. My steering even went out on this lemon of a car.
Feb 24, 2023
Our trim around our windshield came off while driving on a highway. Tried to fix it ourselves but trim replacement would not fit on it properly.
Feb 01, 2023
+ 13 more complaints for this component
STEERING,SUSPENSION
16 complaints
The contact owns a 2016 Ford Explorer. The contact stated that while driving at approximately 35 MPH, the steering wheel became stiff and did not drive as intended. The contact stated that the next morning, she observed a sound emanating from the steering column. The check engine warning light was illuminated before the failure. The vehicle was not diagnosed or repaired. The contact believed that the failure was associated with NHTSA Campaign Number: 20V675000 (Suspension). The manufacturer was not notified of the failure. The failure mileage was approximately 156,580.
Aug 06, 2025
The contact owns a 2016 Ford Explorer. The contact stated that the vehicle was taken to the dealer to be repaired under NHTSA Campaign Number: 19V435000 (Suspension), and the dealer confirmed that the recall repair was performed. However, the contact stated while driving at various speeds on a bumpy road surface, the vehicle jerked significantly, and there was an abnormally loud sound coming from the suspension. The contact stated that the failure progressively worsened, causing the steering wheel to seize. The contact stated that the vehicle had become undrivable. The dealer was notified of the failure and advised the contact that the recall repair had been performed. The manufacturer was contacted and informed the contact that the recall repair had not been performed. The vehicle was not diagnosed or repaired. The failure mileage was approximately 199,000.
Oct 28, 2024
I recently went to a mechanic sho0 to have a wheel alignment done because my steering wheel is about 50% tilted to the left. The shop told me they were unable to align the vehicle because there was a problem with my toelinks in the back of my car preventing the wheel from being straight. I called Ford to see if there was anything they could do because I got my toelinks done when there was a recall back in 2019. I have since had issues with my steering wheel not being lined and thought it was just out of balance. I would like for the toelinks to be looked at once again because apparently there is an issue with them.
Sep 09, 2024
The vehicle became very difficult to steer while on the freeway and then the steering system completely failed. I was able to safely get off the freeway, but I was lucky. This could have been devastating. There were no warning lights until the system shut down. The system issues match exactly the complaints of those who experienced issues with the rear toe link. I live in California, in the Sierra Nevadas in an area with high snow and brine (corrosive) used daily in the winter. The recall is not showing in my area because Ford has deemed all of California as a non corrosive area. This is an extremely dangerous, recognized safety issue which I was not given notice of the recall because Ford mis-catergorized all of California as a non-snow area.
Apr 10, 2023
Driving to work through mountain passes as I live in northern Montana, warning lights came on in dash. Lost power steering ran off road, regained control, took it to ford dealership they said $2200 to fix, I've only had the car just over a month, I pay $750, and now the car sits
Apr 16, 2022
+ 11 more complaints for this component
ENGINE,FUEL/PROPULSION SYSTEM
15 complaints
I WAS DRIVING ALONG AT ABOUT 55 MPH WITH THE CRUISE CONTROL ACTIVATED. THE PEDALS WERE NOT IN THE RIGHT LOCATIONS SO I DECIDED TO ADJUST THEM TO A HIGHER POSITION WITH THE BUTTON ON THE SIDE OF THE STEERING COLUMN. WHEN I DID THE ADJUSTMENT, THE ENGINE WENT INTO A FULL THROTTLE MODE AND WOULD NOT LET UP. I PUSHED DOWN ON THE BRAKES HARD AND VEHICLE SLOWED DOWN AND THE ENGINE RETURNED TO NORMAL. WHEN I TOOK MY FOOT OFF THE BRAKE THE ENGINE IMMEDIATELY WENT FULL THROTTLE AGAIN AND THEN BACK DOWN AGAIN WHEN I PUSHED THE BRAKE PEDAL DOWN HARD. THIS CYCLE CONTINUED EVEN THOUGH I SHUT OFF THE CRUISE CONTROL AND TRIED PUTTING THE SHIFTER IN NEUTRAL. I WAS FINAL ABLE TO PULL OVER TO THE SIDE OF THE ROAD AND SHUT THE ENGINE OFF. I RESTARTED THE ENGINE AFTER A FEW MINUTES AND EVERYTHING SEEMED TO WORK NORMALLY. THIS WAS A VERY DANGEROUS AND SCARY EVENT. I AM AFRAID TO DRIVE THIS VEHICLE OR HAVE MY WIFE DRIVE IT. I REPORTED IT TO FORD BUT HAVE NOT HEARD BACK FROM THEM AT THIS TIME.
May 28, 2019
9/29/18: REMOTE START STOPPED WORKING AND CAR SPUTTERED WHEN STARTING. 10/14/18: AFTER MANUALLY STARTING WITH PUSH-BUTTON, WHITE SMOKE FILLED MY GARAGE AND CAR WITH 3 CHILDREN. EXPLORER TOWED TO BRANDON FORD DEALERSHIP THAT DAY WHICH HAPPENED TO BE A SUNDAY. AS OF TODAY, I STILL DON'T HAVE MY EXPLORER BACK. I WAS INFORMED THAT FLUID GOT INTO THE CYLINDER AND THE CYLINDER NEEDS TO BE REPLACED. UNFORTUNATELY THERE IS A BACKLOG ON THIS PARTICULAR PART. AS I APPROACH THE 5TH WEEK WITH THIS LOANER VEHICLE, I AM WONDERING IF THERE IS MORE TO THE PROBLEM OR IF THERE IS ANYTHING THAT ANYONE CAN DO TO HELP ME GET RESOLUTION.
Nov 11, 2018
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THAT CONTACT STATED THAT WHILE DRIVING, THERE WAS AN ODOR OF FUEL EMITTING INSIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A UNKNOWN LOCAL FORD DEALER FOR A DIAGNOSIS WHERE THE MECHANIC ADVISED THE CONTACT THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT AGAIN WAS DRIVING THE VEHICLE A WEEK LATER, AND SMELLED A FUEL ODOR AGAIN INSIDE THE VEHICLE. THE CONTACT CALLED THE FORD MOTOR COMPANY LOCATED AT 1 AMERICAN ROAD , DEARBORN, MI 48126 (313)322-3000, AND WAS ADVISED TO DROP OFF THE VEHICLE FOR A DIAGNOSIS. THE CONTACT WAS ADVISED THE FUEL PUMP WAS LEAKING FROM A CRACK IN THE PUMP. IT WAS UNKNOWN IF THE MANUFACTURER WAS CONTACTED OR NOT. THE FAILURE MILEAGE WAS 40,000.
Jan 24, 2018
OUR FORD EXPLORER HAS AN EXHAUST LEAK THAT ENTERS THROUGH THE DASH VENTS WHEN DRIVING, OR WHEN PARKED WITH MOTOR RUNNING. WHEN I PARK IN GARAGE. I HAVE TO OPEN BACK AND FRONT GARAGE DOORS TO ALLOW AIR TO "CLEAR " IR FROM GARAGE, SO IT DOES NOT ENTER HOME. OUR FORD DEALER SAID THERE IS NO RECALL.
Oct 30, 2017
THE TAILPIPE OCCASIONALLY EMITS BLUE-GRAY SMOKE, AS IF IT IS BURNING OIL. I HAVE WITNESSED THIS WHEN THE VEHICLE WAS STATIONARY. THE PASSENGER COMPARTMENT OCCASIONALLY SMELLS LIKE SMOKE. THE PASSENGERS IN THE REAR OF THE CAR TEND TO NOTICE IT FIRST, AND THEN THE PASSENGERS IN THE FRONT CAN SMELL IT. IT SEEMS TO HAPPEN WHEN ACCELERATING AT A HIGH RATE, SUCH AS WHEN ENTERING A HIGHWAY FROM AN ON-RAMP.
Oct 20, 2017
+ 10 more complaints for this component
STRUCTURE,UNKNOWN OR OTHER
13 complaints
There was no incident however I received a recall for a windshield piece that was back in 2024 and supposedly would be available for repair in the latter half of 2024. However nothing has been sent to me regarding this and when the piece came off it cracked my windshield so I have a crack across that as well.
Jun 18, 2025
The roof rail on my vehicle became unattached on the interstate becoming hazardous to other vehicles. Worst part is Ford has a recall for roof racks for the year make and model of my vehicle BUT the recall does not include my vehicle as it is not listed under my VIN number. Only because it has not been reported enough to reach the threshold to trigger an investigation and remedy. Ford is not complying with the guidelines that the NHTSA puts forth as even when you are included in the recall the parts /repairs are unavailable. Unacceptable!
Mar 10, 2025
"A" Pillar left and right coming loose, right side blowing away on the freeway. Dealer mentioned they have a fix for it but will not repair until recall approval.
Mar 03, 2025
The recall has been in place for replacing an exterior A-pillar trim part - we have tried to get it replaced, but there are no parts nationally. Why haven't the parts been created? It has been over a year
Dec 30, 2024
The mouldings on the side of the windshield have detached multiple times. There is no warning lights, and I have been told by the dealership and outside repair shops that it is a common problem. Detachment of these parts puts other motorists at risk of injury. July 2021 driver side flew off on the highway - parts on backorder from dealership so they never repaired it. May 2022 had both sides replaced for $160 since they were done at time of windshield replacement. June 2022 passenger side flew off on the highway (no cost replacement since so soon after last replacement). August 2023 passenger side flew off on the highway and hit a semi, $100 repair quote.
Aug 09, 2023
+ 8 more complaints for this component
VISIBILITY/WIPER
13 complaints
Molding on front windshield is damaged and coming off affect visibility
Jan 19, 2025
Trim around windshield becomes loose on highway and rattles against windshield and rubber seals have started coming loose
Jun 20, 2024
The windshield trim blew off while driving on the Highway. Happened so fast I couldn’t tell if it blew into the ditch or what happened to it. Could have easily hit a vehicle behind me and cause an accident. Very distracting for the driver as well. I almost veered into other lane with oncoming traffic with how loud and surprising it was.
Jul 24, 2023
The windshield trim on right side of the car is coming ungluded. Now weather strip is flapping all over the place damaging my passenger window and mirror. I am now noticing trim is coming unglued on drivers side door. I already replaced the passenger door trim a few years back. Please help us consumers by demanding that Ford issue this recall. It is clear this is a defect in their vehicles.
Jun 27, 2023
The windshield cowl is separated from the body of the car and could break apart and hit a car
Jun 04, 2023
+ 8 more complaints for this component
UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM
12 complaints
My check engine light keeps reading a evap code. I have replaced the evap throttle 3x’s. My car smells of a gas leak coming from somewhere. I have taken it to Ford, and to two other mechanics. They claim that the check engine code is wrong and they cannot find where the fuel smell is coming from without the proper code. My check engine light turns on and off with the same error everytime. The evap code is not the problem. I have made a complaint months ago, and still nothing. Not sure what else I can do.
May 31, 2023
EXHAUST IS GETTING INTO THE CAB OF VEHICLE WHEN UNDER MODERATE ACCELERATION TO PASS VEHICLES AND WHEN THE WINDOW OR WINDOWS ARE OPEN IT IS EVEN WORSE.
Aug 06, 2020
ON 3/21/19 I WAS DRIVING WHEN A CAR STOPPED IN FRONT OF ME AND I HIT THEM. MY AIRBAG WENT OFF AND WAS SMOKING BLACK SMOKE. THERE WAS ALSO A FIRE, ABOUT 1.5 FT TALL THAT APPEARED FROM THE PASSENGER SIDE OF THE HOOD. I SAT IN SHOCK UNTIL SOMEONE TOLD ME TO GET OUT. I GOT OUT AND GRABBED MY 4 YEAR OLD DAUGHTER. SHE WAS IN A CAR SEAT AND STILL SECURED AFTER THE ACCIDENT. THANKFULLY WE WERE NOT SERIOUSLY INJURED. WE SAT WATCHING MY CAR QUICKLY ENGULF IN FLAMES. BY THE TIME THE FIRE DEPARTMENT CAME THE CAR WAS PRETTY MUCH ALL BURNED. I LOST A LOT OF VALUABLE AND SENTIMENTAL PERSONAL BELONGINGS IN MY CAR WHICH INSURANCE DOES NOT COVER THE COST OF. IT WAS A TERRIFYING EXPERIENCE TO GO THROUGH FOR MY DAUGHTER AND I. I DO NOT BELIEVE THAT A MINOR ACCIDENT SHOULD CAUSE A FIRE LIKE THIS. I HAVE REACHED OUT FOR FORD MULTIPLE TIMES AND THEY WILL NOT INVESTIGATE WHICH I FIND EXTREMELY FRUSTRATING. I WOULD LIKE TO PREVENT THIS HORRIBLE THING HAPPENING TO SOMEONE ELSE. ALTHOUGH WE WERE NOT INJURED IT COULD HAVE BEEN A LOT WORSE, AND EVEN DEADLY.
Apr 23, 2019
BOUGHT A 2016 FORD EXPLORER SPORT IN NOV.2016 USED WITH 20K MILES. AS I WAS DRIVING HOME I NOTICED A HORRIBLE SMELL AND THOUGHT IT WAS JUST SOMETHING IN THE AREA NEVER DREAMING IT WAS THE CAR! I DID A LITTLE RESEARCH AND FOUND THE CAR HAD A RECALL ON IT. THE SMELL IS HORRIBLE, SO BAD WE HAVE TO RIDE WITH THE WINDOWS DOWN. IM NOT SURE WHY THE DEALERSHIP WAS EVEN ALLOWED TO SELL THE CAR TO ME WITH DISCLOSING THIS PROBLEM. I HAVE TAKEN THE CAR TO MY LOCAL FORD DEALERSHIP AND THEY ARE WAITING ON A RESPONSE FROM FORD. I WOULD LIKE THEM TO BUY THE CAR BACK FROM ME.I AM DRIVING A 2003 CAR NOW WITH 150K MILES BECAUSE I CANNOT DRIVE MY NEW CAR.
Feb 13, 2018
I BOUGHT THE 2016 FORD EXPLORER XLT LAST WEEK FROM A FORD DEALER, I DROVE IT HOME WHICH IS 35-40 MINUTES AWAY FROM THE FORD DEALERSHIP AND BOTH MY WIFE AND I HAD SEVERE HEADACHE. THERE WAS AN ODOR INSIDE THE CABIN WHICH WAS CAUSING THE HEADACHE/NAUSEA. WE COULDNT EXPLAIN WHY THE ODOR WAS THERE AND WHEN WE RESEARCHED ONLINE, WE WERE SHOCKED TO FIND THAT THE FORD EXPLORER HAD THE CARBON MONOXIDE LEAK ISSUE. WE ARE NOT ABLE TO DRIVE OUR CAR FOR MORE THAN 15-20 MINUTES WITHOUT GETTING A HEADACHE.
Jan 20, 2018
+ 7 more complaints for this component
STEERING,ELECTRICAL SYSTEM
11 complaints
There has been many reports of electronic steering issue where it would just swerve you off the road and loose full control while driving for years 2013-2015 cars but 2016 years are also being effected. A dealership confirmed it was an electronic steering rack causing the issue. No warning lamps had went off either
Mar 15, 2024
I was Driven down in Orlando FL while on vacation and 3 notifications popped up on the screen back to back. I pressed Ok to clear the notifications off the screen because I was Unsure what they meant. I soon lost control of my vehicle and was unable to steer. I ended Up veering into another lane and almost hit another vehicle. My boyfriend grabbed the wheel from the passenger side to help straighten it up. I was Thankful that incident did not harm my family or the other family. I get It towed to PepBoys and they inform me I need A new rack and pinion installed and that was going to run me up to $4500. I was Also told in the same sentence that the part I needed Was out of stock or unavailable pretty much everywhere. I contact Another shop and receive a cheaper quote but still no part is available. I contact Ford and speak to an agent. Not very helpful at all. I mentioned I was looking up the part online and read there are recalls on that. The representative asks for my VIN and she tells me there is a recall however not for my VIN. I’m livid. Here it is going into August and still no parts are available. Ford never will I ever Buy another vehicle with that name on it. Found On Road Dead is basically coming to light.
Jul 28, 2023
Vehicle is experiencing a loss of power steering at all speeds. Steering stiffens and loosens erratically. Repair shop reports failure to electronic steering system and state that a replacement of the electronic steering gear assembly is required.
Jul 07, 2023
Rack and pinion power steering rack stopped working while my wife was driving back home with our two kids that are 4 years old and 9 months old. Thankful she didn't crash because she was unable to steer the vehicle. No warnings or signs of the part going bad. Ford should be held responsible for issues like this. Numerous people are having the same issue.
Dec 21, 2022
First problem I had was with the Actuator. I lost the ability of defrost and have the heat/AC go to anything other than direct face mode. Now, the power steering to my 2016 Ford Explorer is gone. It felt like I was grinding concrete when I would make any turn or slight shift. It’s been at the shop for weeks due to a backorder. I’m a single mom of 2 and it’s my only transportation. I’m really struggling without my vehicle. This should be part of a recall ASAP cause from my research this is too common almost this vehicle and good people are really going through it.
Nov 02, 2022
+ 6 more complaints for this component
AIR BAGS,SEAT BELTS
10 complaints
Airbags notification is on
Apr 19, 2024
Car has inflatable seatbelt in the second row bucket seats. I am unable to find any car seats that are safe to use in this vehicle once you move from tether position Have visited local dealership and called Ford for assistance. None of which are able to assist with this which puts children in great harm as no car seat can be safely used
Oct 05, 2023
The 2nd row seatbelts in my 2016 Ford Explorer contain mini-airbags. There is a design flaw that causes the connection to the seatbelts to fail, disabling all airbags in the vehicle. Ford issued a CSP in January of 2021 and was supposed to notify all owners of all affected vehicles. I was never notified. In April 2022 my vehicle was left with a Ford dealership for 1 month due to constant electrical problems- the dashboard would go dark, the car would lose power, the maps would shut down, etc. That dealership repositioned the faulty wires. In December of 2022 the airbag light came on. I had to take it to another dealership and learned because of a failed connection to the 2nd row seatbelt, my car had no operational airbags. I paid approximately $1200.00 for the repair. Ford is refusing to reimburse me for the costs I incurred due to their design flaw. The safety of everyone who has ridden in that car was put at risk- if there was a collision, there would be no protection. The airbag light was not on when the wires were first repositioned. My son drove the car from CT to Florida and was unaware of that the light meant that all airbag s were disabled.
May 13, 2023
MY AIRBAG LIGHT CAME ON AND THE FORD DEALER WARNED ME THAT THE AIRBAGS WOULD NOT DEPLOY UNTIL I GOT THE ISSUE FIXED. THIS IS A KNOWN ISSUE BY FORD, AS THEY HAVE ISSUED TSB IT. MY EXPLORER SPORT IS 4 MONTHS OVER THE 5 YEAR/60,000 MILE POWER TRAIN WARRANTY, SO I CONTACTED ASSURANT SOLUTIONS BECAUSE I BOUGHT A 72 MONTH/75,000 MILE EXTENDED WARRANTY THROUGH USAA ON 1/6/2016. THIS WAS MY FIRST CLAIM AND THEY DENIED THE CLAIM BECAUSE THEY SAID THAT 'SAFETY RESTRAINT SYSTEMS' WAS AN 'EXCLUDED ITEM'! WHAT'S INFURIATING IS THAT THEY COVER ELECTRICAL ASSEMBLY, INTERIOR ELECTRONICS AND POWER TRAIN ELECTRONICS, BUT NOT 'SAFETY' ELECTRICAL COMPONENTS!! I RAISED CANE WITH THE GENERAL MANAGER OF THE FORD DEALERSHIP AND THEY WENT BACK TO FORD FOR A 'GOODWILL' WARRANTY COVERAGE AND THEY AGREED TO PAY FOR ALL BUT $261 OF THE REPAIR. WHILE I SINCERELY APPRECIATE THE GOODWILL OFFER, FORD LOST ANY FUTURE BUSINESS FROM ME FOR NOT PROACTIVELY OFFERING THE GOODWILL COVERAGE FROM THE START BEFORE I HAD TO PURSUE OTHER OPTIONS. SHAME ON FORD!! IT DOESN'T RISE TO THE LEVEL OF A FULL RECALL, BUT IT IS A KNOWN DEFECT WITH A CRITICAL SAFETY FEATURE, SO THEY SHOULD HAVE COVERED IT FROM THE START WHEN PRESENTED WITH THE AIR BAG LIGHT COMING ON! *TR
Apr 09, 2021
UPON STARTING MY CAR FOR THE THIRD TIME THAT DAY MY AIR BAG LIGHT CAME ON AND DOES NOT GO OFF. I ALSO HAVE A PROBLEM WITH IT OCCASIONALLY NOT REGISTERING MY DRIVERS SEATBELT AS BUCKLED OR UNBUCKLED.
Dec 01, 2020
+ 5 more complaints for this component
UNKNOWN OR OTHER,ENGINE,FUEL/PROPULSION SYSTEM
10 complaints
There is a VERY STRONG sulfur odor emiting into the cabin without an engine warning light. Tested for error codes and inspected by Ken Towery in Louisville and the seriviceperson couldn't detect the source of the odor. The defect appeared at 98458. The smell causes me to gag and feel light headed. Please advise.
Mar 16, 2022
WAS DRIVING DOWN 95 @ 65 MPH WHEN ALL OF A SUDDEN, THE CAR JERKED AND LOST ALL POWER. WRENCH LIGHT, CHECK ENGINE, AND AIRBAG LIGHT ALL CAME ON. NO POWER. NO GAS, LIMP MODE. CODE READER DETERMINED THROTTLE BODY ISSUE. LOOKED ONLINE, APPEARS TO BE KNOWN ISSUE IGNORED BY FORD. I COULD HAVE BEEN KILLED
Oct 09, 2019
CAR SMELLS STRONGLY LIKE NATURAL GAS INSIDE CABIN WHEN DRIVING, AND WHEN SITTING STILL - EYES BURN, THROAT SORE, HEADACHE AFTER DRIVING IT FOR 5 MINS OR MORE.
Dec 17, 2017
WHEN ACCELERATING OR GOING UP INCLINE CAR STARTS TO SMELL LIKE CARBON MONOXIDE (LIKE THE HEATER IS ON). CIRCULATION IS WITHIN CAR. IN ORDER TO GET OUT MUST PUT ON OUTSIDE CIRCULATION AND ROLL DOWN WINDOWS.
Sep 25, 2017
CARBON MONOXIDE AND GASOLINE SMELL IN CABIN
Jul 31, 2017
+ 5 more complaints for this component
VEHICLE SPEED CONTROL,ENGINE
9 complaints
The contact owns a 2016 Ford Explorer. The contact stated while driving at various speeds, the vehicle failed to properly accelerate. The contact stated that the failure was intermittent and mostly occurred while driving up an incline. The cause of the failure was not yet determined. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not yet contacted. The failure mileage was 137,000.
Apr 11, 2024
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE ATTEMPTING TO DECELERATE FROM 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE DRIVER WAS ABLE TO COAST ONTO THE SHOULDER. THE ENGINE WARNING INDICATOR ILLUMINATED AFTER THE FAILURE OCCURRED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 10,400.
Aug 25, 2016
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 40 MPH, THE ENGINE SHUT OFF. THE CONTACT TURNED OFF AND RESTARTED THE VEHICLE, AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE MANUFACTURER STATED THAT THEY WOULD LOOK INTO THE MATTER. THE FAILURE WAS NOT REMEDIED. THE FAILURE MILEAGE WAS 7,000.
Aug 18, 2016
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHEN THE ACCELERATOR PEDAL WAS DEPRESSED AT 50 MPH, THE VEHICLE FAILED TO RESPOND AND STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO BE RESTARTED. THE SERVICE VEHICLE SOON AND AIR BAG WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY FAILED. THE VEHICLE WAS REPAIRED TWICE FOR THE SAME FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 18,000.
Jul 08, 2016
THE VEHICLE WAS IN MOVEMENT, GOING 50 MPH, WHEN IT CAME TO A SUDDEN STALL. THE VEHICLE WOULD NOT GO OVER 5 MPH EVEN WHILE PRESSING THE ACCELERATOR. THE WRENCE LIGHT WOULD COME ON AND IT WOULD IT WOULD NOT GO OVER 5 MPH.
Jun 25, 2016
+ 4 more complaints for this component
TIRES
9 complaints
While traveling on I-85N at 70mph, the front passenger tire suddenly came apart from both sidewalls. The tire is a EVOLUXX CAPRICORN 4X4 HP, 255/50R20, 109V, XL. The tire blow-out only caused minor damage to the inner wheel well shroud.
Aug 17, 2023
The contact owns a 2016 Ford Explorer equipt with Bridgestone Dueler Alenza Plus tires size P245/60/18 N/A, and DOT: RBVDRIM0916. The contact stated that while driving approximately 65 mph, a rotational noise was present coming from the front driver side of the vehicle. Upon inspection, it was discovered that the front driver side and passenger side tires had experienced cracking located above the tire bead area on the inside wall of the tire. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure. The failure mileage was 41,000.
Jan 11, 2022
TL* THE CONTACT OWNS A 2016 FORD EXPLORER EQUIPPED WITH HANKOOK TIRES, TIRE LINE: VENTUS S1 NOBLE 2, TIRE SIZE: 255/50/R20, DOT NUMBER: 5MNC 1A H 0716. THE CONTACT BECAME AWARE OF TREAD SEPARATION ON ALL FOUR TIRES. THE CONTACT STATED THAT THE FAILURE WAS MORE SEVERE ON THE TWO FRONT TIRES. THE VEHICLE WAS NOT TAKEN TO HAVE THE TIRES REPLACED. THE CONTACT ALSO STATED THAT THE TIRES FAILED TO MAINTAIN THE PROPER TIRE PRESSURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 16,132.
Nov 09, 2020
TL* THE CONTACT OWNS A 2016 FORD EXPLORER EQUIP WITH HANKOOK VENTUS S1 NOBLE 2; TIRE SIZE: 255/50R20-108H AND THE DOT NUMBER: 5MNC 1A H0118. THE CONTACT STATED THAT WHILE INSPECTING THE TIRES, IT WAS DISCOVERED THAT THE TIRES HAD EXPERIENCED CRACKING AND GUDGES ON THE INSIDE AND OUTSIDE OF THE TIRES. THE FAILURE WAS PRESENT ON ALL FOUR TIRES. THE CONTACT ALSO INDICATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SHAKE AND VIBRATE. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER AUTONATION FORD LOCATED AT 7700 BLANDING BLVD, JACKSONVILLE, FL 32244 WHO REPLACED ALL FOUR TIRES WITH THE SAME BRAND SIZE AND MODEL TIRES BUT APPROXIMATELY 13,000 MILES LATER THE SAME FAILURE HAD OCCURRED. THE CONTACT WAS UNABLE TO REACH OUT TO THE MANUFACTURER IN REFERENCE TO THE FAILURES. THE VEHICLE FAILURE MILEAGE WAS 18,000 AND THE FAILURE TIRE MILEAGE WAS NOT AVAILABLE. THE VIN WAS NOT AVAILABLE.
Aug 25, 2020
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT HE HAD HANKOOK TIRES WHEN HE BOUGHT THE VEHICLE NEW. THE TIRE LINE, TIRE SIZE AND DOT NUMBER WERE UNKNOWN. THE TIRES WERE BALD BY THE TIME THE VEHICLE HAD 11,000 MILES. THE DEALER STATED THAT IT WAS NOT THEIR ISSUE AND TO CALL THE TIRE MANUFACTURER. THE TIRE MANUFACTURER DECIDED TO AWARD THE CONTACT WITH A 20% CREDIT TO BUY SOME NEW TIRES. THE NEW TIRES WERE PLACED ON THE VEHICLE AND THEY WERE ALMOST BALD AT 34,000 MILES. THE MANUFACTURER ADVISED THE CONTACT TO RECALL THE DEALER COGSWELL FORD LOCATED AT 1900 E MAIN ST, RUSSELLVILLE, AR 72801 479-968-2665. THE DEALER HAD NOT BEEN RECONTACTED YET. THE CONTACT RESEARCHED AND FOUND THE ISSUE HAD OCCURRED IN MANY FORD EXPLORERS. THE FAILURE MILEAGE WAS 11,000.
May 18, 2020
+ 4 more complaints for this component
POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE
8 complaints
My vehicles wrench sign would turn on do a little jerk then I would lose power to my car. Showed malfunction to power train. Took it to mechanic said there was a Crack in the valve gasket and they fixed that and changed spark plugs. A month later car did the same thing. Has done it a total for 4 times very scary when on a high way and it does it and I have to pull over with traffic coming. Took it to another mechanic and he couldn't figure it out either because there are no codes but said he seem something similar and I needed to change all my coils. So I did that. Thousands of dollars later and no one can still figure out the problem. I don't know if it's some safety issue with the engine or transmission. But 3 certified mechanics can not figure out why my car continues to lose power.
Mar 21, 2025
THE ACCELERATOR BECOMES UNRESPONSIVE AND MY VEHICLE'S RPM DROPS, REGARDLESS IF I AM PRESSING ON THE GAS PEDAL. MOST NOTABLY OCCURS WHEN DRIVING ON THE FREEWAY, BUT HAS HAPPENED DRIVING WITHIN CITY LIMITS. I HAVE TO PRESS DOWN ON THE GAS PEDAL AND WAIT FOR THE VEHICLE TO EVENTUALLY PICK UP SPEED OR SHIFT GEAR TO NEUTRAL TO DRIVE TO BE ABLE TO ACCELERATE WHEN PRESSING ON GAS PEDAL. THIS IS A SAFETY CONCERN DUE TO THE VEHICLE GOING LIMP MODE, ESPECIALLY ON A FREEWAY. THIS HAPPENS APPROXIMATELY 2-3 TIMES IN A 1 HOUR DRIVING PERIOD. THE LAST TIME THIS HAPPENED THE VEHICLE WRENCH LIGHT WHEN ON AND MY VEHICLE WAS JOLTING WHEN I PRESSED ON THE GAS PEDAL. WHEN I TOOK IT TO THE DEALERSHIP THE WRENCH LIGHT WENT AWAY. IT IS CURRENTLY BEING SEEN BY A TECHNICIAN; HOWEVER, THE TECHNICIAN IS HAVING A HARD TIME DUPLICATING THIS PROBLEM. THIS PROBLEM IS INTERMITTENT. I TRIED TO TAKE IT TO ANOTHER DEALERSHIP PREVIOUSLY FOR THE SAME ISSUE, HOWEVER THEY TURNED ME DOWN DUE TO IT BEING AN INTERMITTENT ISSUE.
Oct 10, 2019
WITH NO WARNING - EXPERIENCED SUDDEN LOSS OF POWER WHILE DRIVING. ENGINE LIGHT CAME ON. ALSO THE WRENCH LIGHT CAME ON WITH A MESSAGE THAT SAID "SEE MANUAL." I WAS ABLE TO GET OUT OF TRAFFICE AND PULL OVER. AFTER TEN MINUTES, I RESTARTED THE CAR. THE CAR STARTED BACK UP WITH NO PROBLEM AND THE ENGINE LIGHT WAS BACK OFF. FROM THERE IT DROVE BEAUTIFULLY LIKE IT NEVER HAPPENED - EXCEPT THAT IT DID ! FOUR DAYS LATER, I TAKE IT TO THE DEALORSHIP. THEY DETERMINED THAT THIS HAPPENED DUE TO A DEFECTIVE THROTTLE BODY. I HAVE TO HAVE IT REPLACED AND IT'S GOING TO COST ME $380. I FIND IT HARD TO BELIEVE THAT WITH THE SIGNIFICANT NUMBER OF COMPLAINTS ON THIS ISSUE ALL OVER THE INTERNET THAT THEY DIDN'T KNOW ABOUT THIS AT THE DEALORSHIP WHEN THEY SOLD ME THE CAR. AND ALSO THAT FORD HAS NOT RECALLED THIS YET CONSIDERING THE NUMBER OF COMPLAINTS. I HAVE TO HAVE THIS FIXED, I HAVE NO CHOICE. I WOULD DEFINITLY LIKE TO REUMBERSED FOR THIS REPAIR. BUT IN ADDITION TO THE OUT OF POCKET COST, THE POWER GOING OUT ON THE CAR WHILE DRIVING IS A MAJOR SAFETY ISSUE. WITH THE SIGNIFICANT NUMBER OF COMPLAINTS ON THIS ISSUE WITH THIS SPECIFIC VEHICLE MODEL / YEAR , I HOPE THAT SOMEBODY DOESN'T HAVE TO DIE BEFORE THEY PLACE A RECALL ON THIS ISSUE.
Jul 31, 2019
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 75 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AND THE VEHICLE STALLED. THE CONTACT STATED THAT THE VEHICLE WENT INTO LIMP MODE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO RETRIEVED DIAGNOSTIC TROUBLE CODE: P2111 (THROTTLE ACTUATOR CONTROL SYSTEM STUCK OPEN). THE VEHICLE WAS NOT REPAIRED. AUTONATION FORD MARIETTA (LOCATED AT 869 COBB PKWY SE, MARIETTA, GA 30060, (770) 674-6077) WAS INFOMRED OF THE FAILURE VIA PHONE. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.
May 28, 2019
DURING ACCELERATION, A BRIEF PAUSE IN ACCELERATION OR DOWN SHIFTING OF GEARS. FEELS LIKE THE TRANSMISSION IS SLIPPING. USUALLY NOTICED DURING 30 MINUTES OF NORMAL DRIVING CONDITIONS.
Feb 14, 2019
+ 3 more complaints for this component
ENGINE AND ENGINE COOLING,ENGINE
8 complaints
The contact owns a 2016 Ford Explorer. The contact stated while driving at an undisclosed speed, there was steam was coming from under the hood. There was an abnormal odor entering into the cabin of the vehicle. The check temperature warning light was illuminated. The contact attempted to refill the coolant; however, the failure reoccurred, and the vehicle was towed. The local dealer was contacted and advised the contact that the water pump might need to be replaced. The vehicle was not diagnosed or repaired due to the cost. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.
Sep 16, 2024
The contact owns a 2016 Ford Explorer. The contact stated while attempting to start the vehicle, the vehicle sputtered with the check engine warning light illuminated. The vehicle was taken to an independent mechanic where the vehicle was diagnosed, and it was determined that coolant was leaking into the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The dealer was contacted but the vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 137,000.
Jul 18, 2024
The contact owns a 2016 Ford Explorer. The contact stated there was an unknown fluid leaking underneath the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer and the contact was informed that the internal water pump was leaking and that the water pump needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 12,000.
Aug 02, 2023
The contact owns a 2016 Ford Explorer. The contact stated while cold starting the vehicle, the check engine warning light was illuminated. The contact stated that the vehicle seemed to be operating normally; however, the check engine warning light remained illuminated. The contact stated that after a week with the check engine light remaining illuminated, the vehicle was driven to a local dealer where it was diagnosed and determined that the long block needed to be replaced. The vehicle had not been repaired. The contact researched online and related the failure to manufacturer Customer Satisfaction Program Number: 21N12 - Short Block Replacement After Coolant Intrusion (Engine and Engine Cooling). The manufacturer had been informed of the failure. The failure mileage was approximately 72,000.
Jul 21, 2023
The contact owns a 2016 Ford Explorer. The contact stated that when the vehicle was taken to an independent mechanic for a routine oil change, he was made aware that there was coolant intrusion into the engine, and that the water pump, head gasket, and timing belt needed to be replaced. No warning lights were illuminated. The contact was advised to have the repairs completed at a local dealer. The contact made a local dealer aware of the failure; however, the vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 75,000.
Feb 23, 2023
+ 3 more complaints for this component
ELECTRICAL SYSTEM,AIR BAGS
8 complaints
My vehicle had a rear seat air bag recall. i brought the vehicle in for the recall and during a test of the airbag system the driver side air bag had a fault and the harness was replaced. Ford indicated that the vehicle airbag system is operational. I got a airbag light come on the dash and an appointment was made. They told me that the passenger side airbag harness is defective. They would not repair the issue because they said that the recall had been resolved and this is a new one? I feel that they did not resolve the issue since it is a electrical harness issue that needed a recall for the entire vehicle. since they said the fixed the driver side they will not honor the recall. I feel this is not fair for the consumer and the safety of the passengers. I feel that there should be another recall on all airbags electrical harness. I feel that they did not complete the job since it was the same issue that caused the recall for the rear seat should cover all airbags in the vehicel.
Mar 01, 2023
Vehicle displays airbag warning light. Dealership diagnostic test determined there is a faulty connection to the 2nd-row inflatable seatbelt sensor. Ford issued a service bulletin to replace the wire harness pigtail connection. When the airbag light is illuminated due to this faulty connection, all of the airbags in the vehicle are deactivated. Directly from site: Https://Ford.oemdtc.com/1203/air-bag-warning-light-illuminated-with-dtc-B141B-B141C-2014-2016-Ford-Explorer tsb 16-0001 airbag warning light illuminated with diagnostic trouble code (dtc) B141B and/or B141C. This is not normal wear and tear but a safety item design by Ford that has failed in the vehicle. Ford dealership claims that this is not warranty failure. Cost to repair $1085 plus $230 diagnostic test charge.
Aug 05, 2021
AIR BAG LIGHT ON DASH. CAUSED BY DTC B141B. FOUND TSB RELATED TO CONNECTORS UNDER REAR SEAT MP 130. CAR WAS STATIONARY.
Apr 15, 2021
THE 2ND ROW AIRBAG LIGHT CAME ON, AND FORD TOLD ME IT WAS A SHORTAGE IN THE WIRES AND IT WASN'T COVERED UNDER THE MANUFACTURERS WARRANTY. THEY STATED THAT SINCE THE AIRBAG LIGHT WAS ON, THE SHORT IN THE WIRING WOULD STOP THE AIRBAG FROM DEPLOYING, WHICH IN TURN IS A SAFETY ISSUE.
Apr 13, 2021
AIRBAG LIGHT HAS BEEN COMING ON INTERMITTENTLY FOR OVER 1 YEAR. DIAGNOSTIC TEST DETERMINED THERE IS A FAULTY CONNECTION TO THE 2ND ROW INFLATABLE SEATBELT SENSOR. FORD ISSUED A SERVICE BULLETIN TO REPLACE THE WIRE HARNESS PIG TAIL CONNECTION. WHEN THE AIR BAG LIGHT IS ILLUMINATED DUE TO THIS FAULTY CONNECTION, ALL OF THE AIR BAGS IN THE VEHICLE ARE DEACTIVATED. THIS IS EXTREMELY DANGEROUS, AND MY FAMILY HAS BEEN DRIVING THE CAR IN THIS CONDITION FOR OVER A YEAR. UPON FURTHER RESEARCH, NUMEROUS CASES EXIST REPORTING THE SAME ISSUE. PLEASE ADDRESS THIS SAFETY ISSUE.
Jan 18, 2021
+ 3 more complaints for this component
ELECTRICAL SYSTEM,ENGINE
7 complaints
The water pump failed vehicle only has around 105,225 miles on it. This has been a known issue with the 3.5L Twin turbo ecoboost. The water and coolant continuously coming out happens to be on the alternator which has caused it to short out and no longer be working properly. There has not been any kind of malfunction or warning lights for any of the issues and because of the way ford designed the water pump to be inside the motor working off the timing chain it turns into what the book lists at 14-15 hours to complete. The motor has to come out taken apart to replace the water pump and with that not just one but both timing chains have to be set again which adds additional hours for the repair and of course more money to take it to a ford shop to have it fixed the rough estimate which they said did not include the labor for the timing chains being set nor the price of any of the parts needed as I have already purchased them myself so only labor for the water pump (not including timing chains) is about $4,350.00 + tax of course but they said that would increase because of the labor for the timing chains that you have no option or choice regarding having to work on them or not because of the water pump. oh and none of that includes rental fees while repaired nor the price to get and replace the alternator and labor for that. so my guess would be somewhere around $6,000 give or take to fix this disaster and Ford does not care about their known failed design and flawed water pump issues and expect someone to be able to fork out that kind of money instead of trying to help fix there issue.
Aug 21, 2024
water pump blew up at 120k miles, motor locked up leaving me in the middle of the road
Sep 09, 2023
On 6/16/22 my vehicle was put in the shop for overheating. It was a water pump leak. It is a timing chain run water pump. The water pump is located in the engine. It was a very expensive repair. Due to the amount of labor this took to fix I was out of a vehicle for almost a month. I paid for the repair. Less that a week after I got it back my AC stopped working. Back to the shop it went. More money later... Mechanic explained to us that the water pump is located on top of the compressor. When it leaked it got all over everything destroying it. Now I must get a new compressor. No telling what else it ruined under there. This is a huge problem with this year model of Ford. Matter of fact in Canada it has already been recalled. Why is this problem not getting recalled in the US? Many people have gone after Ford with no luck and one judge threw of the case.
Jul 30, 2022
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING 35 MPH, THE VEHICLE STALLED WITHOUT WARNING AND LOST POWER. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO STEVE ROGERS FORD (LOCATED AT 9760 OH-64, WATERVILLE, OH 43566, (419) 878-8151) TO BE DIAGNOSED. THE MECHANIC WAS UNABLE TO RETRIEVE A FAULT CODE OR DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT AND PRIMARILY OCCURRED DURING HOT, HUMID WEATHER WITH THE AIR CONDITIONING ACTIVATED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 72,400.
Oct 04, 2018
I WAS DRIVING ON THE NYS THRUWAY AROUND 70-75MPH AND THE CAR DECELERATED TO 55MPH THEN WAS LIKE IN A COAST MODE. THE WRENCH LIGHT CAME ON AND IT SAID SEE MANUAL. I PUSHED THE PEDAL ALL THE WAY TO THE FLOOR AND IT WOULD NOT GO ANY FASTER. I WAS ABLE TO COAST TO THE SIDE OF THE ROAD. I TURNED CAR OFF AND THEN TURNED IT BACK ON AND PUSHED OK TO THE SEE MANUAL. I WAS THEN ABLE TO DRIVE IT. WE COULD OF BEEN KILLED IF SOMEONE WAS BEHIND ME. I BROUGHT IN TO DEALER AND SAID THEY REALLY DIDN'T FIND ANYTHING WRONG OR SEE ANY INFO ON THE COMPUTER WHEN CAR WAS HOOKED UP. VERY SCARY AS I HAVE READ ONLINE MORE PEOPLE HAVE HAD THIS HAPPEN TO THEM.
Sep 10, 2018
+ 2 more complaints for this component
POWER TRAIN,VEHICLE SPEED CONTROL
7 complaints
The contact owns a 2016 Ford Explorer. The contact stated while stopped, the engine was idling rough. The contact stated that while accelerating, the vehicle was slow to respond and then jolted forward. While driving, reversing, or at a stop, the vehicle was shaking abnormally. There were no warning lights illuminated. The vehicle was taken to an independent mechanic, who determined that the failure was due to the torque converter. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 94,400.
Jul 01, 2024
While driving on the interstate my transmission decided to stop working. I was not able to safely get off the interstate because this happened going up an incline. My explorer will not shift into any gear and the cost to replace the transmission is $5300. Ford stated that the recall #20B27 was completed on my car in 2020 but when I called after the transmission died they stated that my VIN was not eligible for the #20B27 recall. So, how was it completed if they are now saying the recall wasn’t for my car? My explorer is a 2016/2.3L/6F35 Transmission code/built in Chicago. Ford needs to recall and replace every transmission in these explorers. With so many complaints and transmission failures/problems I’m floored that nothing has been done to remedy this situation that many explorer owners are experiencing. Do better Ford.
Jun 01, 2024
The contact owns a 2016 Ford Explorer. The contact stated while driving at various speeds and while idling, the vehicle was vibrating abnormally. The dashboard was shaking, and the glove box was rattling. While shifting from park to drive or reverse, the vehicle vibrated. Additionally, the vehicle was hesitating and misfiring during acceleration. The vehicle was taken to the local dealer but was not diagnosed or repaired. The manufacturer was contacted, and the contact was referred to the NHTSA Hotline. The failure mileage was approximately 58,000.
Mar 02, 2023
THE CAR LOOSE THE POWER AND DON'T GO OVER 20 MILES AN HOUR . RPM GOES OVER 5000 CAR SPEED DON'T CHANGE MAKE NOISE YOU CAN'T GO UP THE HAVE THE POWER TO GO ONLY 20 MILES TO 23 MILES AN HOUR
Mar 23, 2021
MY FAMILY AND I WERE AT A A GAS STATION ABOUT TO GET ON THE FREEWAY WHEN MY FORD EXPLORER STARTED TO STALL. I PULLED TO THE SIDE AND TURNED IT OFF AND BACK ON. THIS ACTION SEEMED TO FIX THE PROBLEM; HOWEVER, AFTER THAT DAY (4 MONTHS AGO) THE FORD EXPLORER HAS BEEN STALLING EVERY TIME I START IT AND START TO PULL OUT OF MY DRIVE WAY. IT WILL LOSE SPEED WHEN I TRY TO ACCELERATE AND WILL STALL FOR THE FIRST MINUTE OR SO BEFORE RESUMING BACK TO NORMALS I AM NOW AFRAID TO DRIVE THIS VEHICLE WITH MY FAMILY AS IT DOES NOT FEEL SAFE AT ALL. ADDITIONALLY, AFTER STALLING I WILL GET THE WRENCH SYMBOL ON MY DASH.
Mar 29, 2020
+ 2 more complaints for this component
STEERING,ELECTRONIC STABILITY CONTROL (ESC)
7 complaints
I WAS DRIVING HOME FROM DROPPING MY DAUGHTER OFF AT DAYCARE AND I LOST THE POWER STEERING ON MY VEHICLE WHILE THE VEHICLE WAS IN MOTION AND I WAS DRIVING A STEADY SPEED DOWN A STRAIGHT ROAD. MY DAUGHTER WAS NO LONGER IN THE CAR WITH ME AS THIS COULD HAVE RESULTED IN AN ACCIDENT BUT THANKFULLY SHE WAS NOT AND I WAS ABLE TO PULL OFF THE ROAD WITH A LOT OF EFFORT INVOLVED. MY CAR HAD TO BE TOWED TO THE FORD SHOP AND I HAD TO HAVE MY POWER STEERING CORE CHANGED. $2500. THIS CAR ONLY HAS 37,000 MILES AND IS A 2016 FORD EXPLORER. QUITE FRUSTRATING, DISAPPOINTING AND EXPENSIVE. THERE NEEDS TO BE A RECALL WITH THIS PROBLEM BECAUSE I AM NOT THE ONLY ONE THIS HAS HAPPENED TOO.
Aug 25, 2020
AFTER GETTING MY AIRBAG RECALL TAKEN CARE OF I NOTICED THE STEERING STARTED GETTING TIGHT MORE AND MORE AFTER 2 DAYS IT WAS REALLY TIGHT UNTIL IT RAINED AND IT GOT LOOSE AGAIN BUT THE STREET LINE SENSORS AND THE RUMBLE STOPPED WORKING. ONE DAY AFTER THE RAIN DRIED THE WHEEL TIGHTEN UP AGAIN WHERE I CAN BARELY TURN IT. I ASK FORD ABOUT IT AND THEY SAID I HAD TO GET A DIAGNOSTIC FOR $179 TO DETERMINE WHAT WAS WRONG. ALSO HAVE A PROBLEM WITH THE EMISSIONS PASSING BECAUSE THE AIR FILTER SENSOR IS NOT WORKING. TRYING TO GET AN OUTSIDE MECHANIC . FORD IS A RIPOFF.
Apr 20, 2020
I WAS DRIVING DOWN THE HIGHWAY AND I GOT ERRORS SAYING MY ADVACE TRAC SYSTEM NEEDED TO BE SERVICED. ALSO THAT MY POWER STEERING FAILED AND I NEEDED TO PULL THE VEHICLE OVER SAFELY. I WAS GOING ABOUT 65MPH AND MY POWER STEERING WENT OUT!. I HAD TO TAKE AN OFFRAMP SHORTLY AFTER (I WAS ON MY WAY TO WORK) AND IT WAS DIFFICULT TO STEER THE VEHICLE. VERY DANGEROUS!
Dec 06, 2019
WHILE DRIVING DOWN THE ROAD MY POWER STEERING WENT OUT. I HAVE AROUND 50,000 MILES ON MY 2016 FORD EXPLORER. I HAVE HAD IT WORKED ON 3 TIMES AND IT CONTINUES TO HAVE THE SAME ISSUE. THIS IS A SERIOUS SAFETY ISSUE FOR THE PEOPLE IN THE CAR AND THOSE ON THE ROAD. MANY PEOPLE HAVE COMPLAINED ABOUT THIS ISSUE, YET FORD HAS NOT ISSUED A RECALL.
Sep 10, 2018
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 70 MPH, THE POWER STEERING SUDDENLY FAILED AND MADE THE STEERING WHEEL VERY DIFFICULT TO TURN. DURING THE FAILURE, THE "STEERING FAULT" AND "SERVICE ADVANCE TRAC" MESSAGES DISPLAYED. THE VEHICLE WAS TOWED TO THE LOCAL DEALER (TOMS FORD, 200 HWY 35, KEY PORT, NJ) WHERE IT WAS DIAGNOSED THAT THE POWER STEERING ASSEMBLY WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 71,000.
Aug 01, 2018
+ 2 more complaints for this component
POWER TRAIN,UNKNOWN OR OTHER
6 complaints
I experienced two failures associated with other model years. The first was the right side A-pillar trim. It pulled free on the highway. I noticed it fly off and was able to recover the majority of it. It smashed on impact and there is a large piece missing. The remaining piece is available for inspection upon request. The A-pillar exterior trim flew off on a one-lane section of divided highway, there would have been no place for anyone to go if it flew back and there was a car behind me. This problem is a known issue I found out about on this (NHTSA) website. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No, it flew off on the highway and has not been reported yet. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No warning at all that this was going to break loose. I also have an issue with the PTU. I was driving home from the airport and at a a stoplight, I noticed a ticking noise when I stopped at the exit of the parking lot. I noticed it again closer to home, after a fifty mile drive. When I stopped on the off ramp from the highway, I noticed smoke coming from under/behind my explorer. It smelled like antifreeze, but when I arrived home, and checked under the vehicle, I found black residue on the PTU and what looked like leaks from the axle seals that were not there for the last five months I've owned the vehicle. The vehicle smoked heavily when I stopped on the exit ramp, and when I went to accelerate into the traffic round-about, the vehicle lagged before moving, with an audible clunk and a lurch when it finally moved. Any reasonably hard acceleration produces a noise and will usually lag before moving. It may make a ticking noise when at idle cold, but is more pronounced the hotter the drivetrain gets. I had an OBD II scan done with no codes produced.
May 08, 2025
The second time my water pump has gone out in this vehicle. Causing over heating of the car and unrepairable wiring. Ford needs to get it right for us 2016 Ford Explorer owners. They [XXX] when it came to this vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mar 11, 2025
Ptu burnt out less than 53k miles. Molding on passenger side broke off while driving 60mph struck another vehicle causing to other vehicle to leave road. Thank God no one was injured. This thing could have killed a motorcycle driver. Checked online and there are thousands of reports of same molding breaking off while driving.ford tn# does not recognize and disconnects call.
Feb 25, 2025
Was driving on I-40 at approximately 75mph and vehicle lost all acceleration, wrench icon came on in dash. Pressed. Gas pedal to the floor, no acceleration. Had to pull over on side of road. Pulled over vehicle stared shaken. Cut off vehicle for about 1min. Tried to retest vehicle, vehicle did not want to restart/crank. Tried again vehicle stared up. Vehicle power is not the same. Thank God I was on the right side of the highway instead of the middle so I could get off the road. This could have been worse.
Aug 23, 2021
WHEN KEEPING A STEADY SPEED, RPMS FLUCTUATE UP AND DOWN CAUSING A JERKY MOVEMENT WHILE DRIVING. HAPPENS RANDOMLY OR AFTER IDLING FOR A FEW MINUTES. ALSO, POWER DECREASES DURING THIS EVENT, SO WHEN TAKING OFF, CAR DOESN'T WANT TO ACCELERATE, THEN LURCHES FORWARD. ALSO, WHEN ACCELERATING, PARTICULARLY UPHILL, A BURNING SMELL COMES FROM THE VEHICLE.
Apr 17, 2018
+ 1 more complaint for this component
STEERING,UNKNOWN OR OTHER
6 complaints
Rack and pinion failure. Caused me almost to wreck. Cost is $4200 to fix. Ford has to program it and send it back to my mechanic. I’m lucky this didn’t go out while going down a hill that would have been very bad.
Sep 21, 2024
I am writing to you as I just read an article about my Explorer being recalled for a different issue, pieces of trim flying off (which happened to us several years ago). I took to the dealership then, they replaced and it immediately cracked again. They were blaming my door as being off and causing the damage. I took to a repair shop (non-Ford) to look at and they told me that they had seen this alot and Ford knew there was a problem and it wasn't my door. It made me extremely upset as it almost caused an accident while we were on the freeway. This complaint is for a completely different safety issue and is recent. I am mentioning the above incident as my car this time was taken to a different repair shop. Their response was very similar to the above repair shop that Ford knows there is a problem as the part is on a national backorder. After a recent snowstorm, my husband went to drive his car to work. The storm had passed, but roads were still dangerous. As he was pulling out of the garage, multiple alarms showed up on the dashboard. "Hill Start Assist Not Available", Service AdvanceTrac, "Steering Assist Fault Service Required". He didn't fully know what any of these meant and had just driven the car the day before with no issues. As soon as he pulled out on the roads, he realized the power steering was out. He is lucky that he didn't crash as the roads were still icy and snow covered. Up until these alarms, there was NO warning. What if it happened while in the middle of driving? I drive that car every day w my kids and my husband took it that Sunday as it is better in snow. I can't even imagine what would have happened if I was driving as there is NO WAY I could have steered that car. Somehow we got the last replacement part (repair was over $3000!) and I only have 68,000 miles on my car. How can a part that is on an older Ford be on national backorder if there isn't a major problem! The rack and pinion w computer module was replaced.
Jan 24, 2024
In the past week or two I have noticed the steering in my 2016 Ford Explorer starting to feel "heavy" and that progressed to being really stiff and kind of hard to turn. Called Ford and they advised to have the vehicle examined. Took the car to my preferred repair facility and there were no codes for an issue; they found my battery was bad and suggested changing it to see if that would help the steering. Battery was replaced and still issues with the steering, the mechanic at my facility said "the rack is still bad". I will make contact with Ford again however based on the number of complaints I see from others I am sure that will get me no where. It appears there are hundreds of complaints about this issue I see for the 2016 Explorers, and many others from prior years too. And these are just the people who have taken the time to complain. This clearly can turn into a large safety issue if people aren't able to control their vehicles while operating. I have no issue with making repairs to my cars, things break. I do have an issue with having to go into my own pocket to fix issues that are a known problem. While not safety issues I also have two other seemingly "known" issues with my car. The rear air conditioning line is leaking so my air is out; and the paint on my hood is bubbling and chipping away, apparently an issue with manufacture of the hood.
Jun 28, 2023
WHEN I GO TO TURN, IT CONTINUES TO POP. THE TIE RODS HAVE BEEN REPLACED ALONG WITH RACK AND PINION BUT YOU COULD BE STOPPED AND APPLYING BRAKE AND TURN WHEEL AND IT POPS.
Nov 17, 2020
THE FIRST TIME MY STEERING GOT STIFF ON 09/13/2019 WHILE TRYING TO MAKE A LEFT TURN ON A CITY STREET. IN THE PROCESS OF MAKING THE LEFT TURN MY STEERING WHEEL GOT STIFF, AND THE STEERING FAULT HILL START AND TRAC LIGHT WENT ON. I WAS UNABLE TO CONTROL THE STEERING WHEEL WHICH CAUSE ME TO GET UP ONTO THE SIDE WALK AND ALMOST HITTING A TREE. I HAD TO SLAM ON MY BREAKS IN ORDER TO AVOID THE ACCIDENT. MY KIDS BODY JERK BACK AND FORTH REALLY HARD. I TURN MY CAR OFF AND BACK ON, AND THE STEERING WHEEL WAS WAS NO LONGER STIFF AND WORKING. I WAS ABLE TO DRIVE HOME. THE SECOND TIME STEERING WHEEL GOT STIFF WAS ON 10/05/2019. WHILE ON THE CURVE OF A RAMP TO GET OFF THE FREEWAY THE STEERING WHEEL GOT STIFF AGAIN AND THE STEERING FAULT, HILL START AND TRAC LIGHTS WENT ON AS WELL. ONCE AGAIN I HAD TO SLAM ON THE BREAKS IN OR. I DER TO AVOID HITTING THE RAILS, AS I WAS NOT ABLE TO CONTROL THE STEERING WHEEL. I TRY TURNING MY CAR OFF AND BACK ON AGAIN TO SEE IF MY STEERING WHEEL WOULD WORK AGAIN, BUT IT STILL DID NOT WORK. I HAD TO CALL MY HUSBAND TO COME PICK ME UP. I TOOK THE CAR TO THE DEALER AND I WAS TOLD THAT THEY H.AD TO REPLACE THE WHOLE POWER STEERING EQUIPMENT WHICH COST ME A TOTAL OF $2350.39
Oct 10, 2020
+ 1 more complaint for this component
POWER TRAIN,UNKNOWN OR OTHER,ENGINE
6 complaints
You can smell a sickly metal burning smell in the cabin when accelerating to get onto a freeway.
Aug 29, 2022
Check engine light came on low engine oil pressure light come on made loud knocking noise regular maintenance 147k miles vehicle is at mechanic shop estimate total $1500-$2500 to fix do not have money for repairs
Aug 09, 2022
WHEN YOU DRIVES SLOWLY IN BETWEEN 15MPH TO 20MPH 2ND TO 3RD GEAR SHIFTING IT GAVES TUGG WHEN IT WAS IN WARRENTY I BRING TO FORD DELARSHIP BUT THEY SAID EVERYTHING IS OK NEVER RECOMMEND FORD IT WAS MY 1ST EXPERIENCE WITH FORD BUT ALL CRAP CARS AND SUVS
Jan 18, 2019
SMELL EXHAUST FUMES INSIDE CABIN OF VEHICLE. EXPOSURE TO CARBON MONOXIDE CONCERN. HAPPENS DURING FULL ACCELERATION AND DRIVING UPHILL AND WITH A/C UNIT ON.NOTICED UPON LEASE RECEPTION. FORD REPLACED EXHAUST SYSTEM BUT NOT HELPED, ACTUALLY NOW WORSE. ONGOING ISSUE UNRESOLVED.
Feb 15, 2017
I WAS DRIVING CLOSE TO MY HOUSE AND ALMOST CAUSED A BIG ACCIDENT WHILE I HAD MY CHILDREN ON BOARD. THE CAR STOPPED COMPLETELY ( SUDDENLY STOPPED) AND LOST POWER, I WAS LUCKY THAT NOT ACCIDENT OCCURRED ( CAN U IMAGINE IF I WAS IN THE MIAMI EXPRESSWAY AND THAT HAPPENED). I'M ATTACHING A PIC SHOWING THE CHECK ENGINE, WRENCH LIGHT THAT CAME ON WHILE I WAS DRIVING. I DID SOME RESEARCH ONLINE AND FOUND OUT THAT MANY AMERICANS ARE HAVING THE SAME ISSUES, IT IS A DEFECTIVE THROTTLE BODY THAT CAUSES THE VEHICLE TO SLOW DOWN AND SHUTDOWN AT ANY TIME. FORD IS ALREADY AWARE OF THE PROBLEM AND YOU GUYS MORE LIKELY ARE AWARE TOO. WHAT ARE YOU GUYS WAITING TO ISSUE A RECALL?? WAITING FOR SOMEONE TO DIE?
Jul 10, 2016
+ 1 more complaint for this component
VISIBILITY,STRUCTURE
5 complaints
The contact owns a 2016 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure). The contact stated that water was leaking onto the passenger’s side floorboard and passenger’s side door, causing an electrical short with the windows. The contact stated that the window was stuck. The contact left the windows opened to air out the vehicle. The contact used duct tape to secure the structure. There were no warning lights illuminated. The local dealer was contacted and confirmed that parts were not yet available. The contact was added to a waiting list. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 86,800.
Aug 14, 2025
The contact owns a 2016 Ford Explorer. The contact stated that after it had rained, water entered the vehicle through the sunroof and would accumulate inside the roof of the vehicle. While coming to a stop while driving, the water would flow to the front of the vehicle and leak inside the cabin through the ceiling light console. The contact had taken the vehicle to a dealer on multiple occasions where they replaced the flooring and the sunroof; however, the failure returned after each repair. The vehicle was also taken to an independent mechanic where the contact was informed that the drain tube inside the sunroof had become clogged which resulted in water accumulation inside the vehicle. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the NHTSA Hotline. The vehicle was not repaired. The failure mileage was unknown.
Oct 03, 2023
The contact owns a 2016 Ford Explorer. The contact stated while driving 65 MPH, the driver’s side windshield side trim loosened. The contact pulled over on the side of the road and placed the trim back in place, but the failure reoccurred. The dealer was contacted, and the dealer stated that the part was okay as-is. The manufacturer was contacted and stated that the vehicle needed to be inspected. The failure mileage was 110,000.
Feb 21, 2023
The contact owns a 2016 Ford Explorer. The contact stated that while driving approximately 55 MPH, the A and B molding used to secure the windshield, detached from the vehicle. The contact pulled over and retrieved the pieces. The contact had taken the vehicle to the dealer who replaced the moldings. The contact stated that the front windshield molding had since started to detach again. The contact stated that the rear and front passenger’s side door moldings were also detaching. The contact returned the vehicle to the dealer and was informed that the repair was not covered under warranty. The manufacturer was made aware of the failure and confirmed that there was no recall regarding the failure. The contact was referred to the NHTSA Hotline. The approximate failure mileage was 83,913.
Sep 14, 2022
The contact owns a 2016 Ford Explorer. The contact stated while driving 70 MPH, the contact heard a knocking noise from the front driver’s side window. The contact pulled over to the side of the road and inspected the vehicle and noticed that the weatherstrip on the front driver’s side door was detaching from the molding that held the weatherstrip from the windshield. The contact pushed the weather strip back into the molding and continued to drive back to the residence. The contact took the vehicle to an independent mechanic who inspected the vehicle and stated that the weatherstrip had loosened over time. The mechanic glued the weather strip back into the molding as a temporary fix and referred the contact to a local dealer for assistance. The contact took the vehicle to the local dealer and was informed that the molding needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 58,000.
Sep 01, 2021
ELECTRICAL SYSTEM,STRUCTURE
5 complaints
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V347000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that water was entering the cabin of the vehicle through the A-pillar and B-pillar trims, sunroof, and doors. The contact stated that the water had started to affect various electrical systems. The contact stated that the A/C unit failed to cool as prior to the failure. Additionally, the turn signals failed to self-deactivate. The vehicle was taken to the dealer but was not diagnosed or repaired. The vehicle was not repaired. The manufacturer was made aware of the failure and opened a case. The failure mileage was 142,000. VIN tool confirms parts not available.
Jun 30, 2025
The contact owns a 2016 Ford Explorer. The contact stated that while the vehicle was parked, the front passenger side door was opened, and the contact noticed water on the carpet after it had rained overnight. The vehicle was not diagnosed or repaired. The contact stated that on another occasion, while driving 25 MPH, during a rainstorm, the contact noticed water leaking from the front windshield. Additionally, there was water leaking from the dome light into the vehicle. The contact became aware of failures with the electrical system. However, the vehicle was not diagnosed or repaired due to the cost for the most recent failure. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 100,000.
Jun 17, 2025
The contact owns a 2016 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 19V435000 (SUSPENSION), 24V031000 (Structure), and 25V347000 (STRUCTURE). However, the parts to do the recall repairs for 24V031000 (Structure) and 25V347000 (STRUCTURE) were not yet available. The contact stated that while driving at an undisclosed speed, the driver's side A-pillar detached from the vehicle. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that on a separate occasion, while the vehicle was idle and the contact was dropping off her child at school, the rear passenger seat caught on fire. The contact had turned on the seat warning, and when the daughter exited the vehicle, an abnormal burnt smell was coming from the back seat. The contact then noticed smoke was emitting from the seat. The contact pulled over to the side of the road, turned off the engine, and put out the fire. The seat was damaged beyond repair, and the wires were exposed. The vehicle was not diagnosed or repaired for the most recent failure. No Fire and Police reports were filed. There were no injuries sustained. The manufacturer was not made aware of the issue. The failure mileage was unknown. VIN tool confirms parts are not available.
Jun 12, 2025
The contact owns a 2016 Ford Explorer. The contact stated that rainwater had leaked into the driver's side B-pillar trim panel causing electrical failures to occur which included the battery failure and the keyless entry failure. The cause of the failure was not yet determined. The local dealer was notified of the failure, but no assistance was offered. The failure mileage was 125,000.
Mar 15, 2024
RADIO SPARKING AND SMOKING PLUS PEELING AND BUBBLES INSIDE THE HOOD PAINT
Apr 17, 2021
SERVICE BRAKES
5 complaints
I believe the 2016 Ford Explorer that I own was sold to me with the wrong front brake rotors. The issue with the rotors became apparent after removing the tires. Component has not been inspected by manufacturer, police, or insurance representative. No warning lights appear on instrument panel. A weird stutter is happening an I think it’s causing issues with the transmission.
Mar 17, 2025
Same issue as NHTSA campaign number: 22V150000 The problem: The brake master cylinder may allow brake fluid to leak from the front-wheel circuit into the brake booster.
Dec 22, 2022
Bad sudden brake fluid leak problems, alarm on car alerting to extremely low brake fluid warning. Have refilled a couple times but the leak is bad and for no apparent reason. Other similar years of ford vehicles have been recalled for the low brake fluid reason.
Apr 25, 2022
2016 FORD EXPLORER. CONSUMER WRITES IN REGARD TO BRAKE FAILURE WHILE DRIVING. *AS THE CONSUMER STATED AS A RESULT OF THE CONTINUOUS FAILURE, THE VEHICLE WAS TRADED IN. *JS
Jan 06, 2021
WHILE IN MOTION ON CITY STREET AT 45 MPH, BRAKES FAILED TO RESPOND IN EXPECTED MANNER. PRESSING BRAKE PEDAL AS FAR AS POSSIBLE, THERE WAS ALMOST NO BRAKING ACTION TO SLOW VEHICLE.
May 28, 2016
ELECTRICAL SYSTEM,AIR BAGS,SEAT BELTS
5 complaints
The problem remedied by TSB 21B11-s2 did not occur in my vehicle while the TSB was in effect. It has now surfaced
Jan 04, 2025
The airbag light comes on due to the connectors in the wiring harness used for the airbag and seatbelt restraint system. When the light is on the airbags will not deploy, making this a safety related issue. Ford has a technical service bulletin Ford TSB 16-0001 showing the issue. This is not covered for repair and the cost is $900.00 to $1100.00 per side (there are two sides) to replace the wire harness and connectors. https://www.tsbsearch.com/Ford/16-0001
Jan 11, 2022
THERE IS AN SRS AIRBAG WARNING LIGHT ON THE DASHBOARD THAT USED TO INTERMITTENTLY DISPLAY. NOW IT IS ON CONSISTENTLY WHEN THE VEHICLE IS DRIVEN. IT IS DUE TO A CIRCUIT FAILURE OR A BROKEN CORD LEADING TO THE DRIVER SIDE MIDDLE ROW SEATBELT AIRBAG. DIRECTLY FROM SITE: HTTPS://FORD.OEMDTC.COM/1203/AIR-BAG-WARNING-LIGHT-ILLUMINATED-WITH-DTC-B141B-B141C-2014-2016-FORD-EXPLORER TSB 16-0001 AIR BAG WARNING LIGHT ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) B141B AND/OR B141C THIS IS NOT NORMAL WEAR AND TEAR BUT A SAFETY ITEM DESIGN BY FORD THAT HAS FAILED IN THE VEHICLE. FORD DEALERSHIP CLAIMS THAT THIS IS NOT WARRANTY FAILURE. BUT SOUNDS LIKE AN ELECTRICAL AND SAFETY ISSUE TO ME...WHICH SHOULD BE COVERED UNDER WARRANTY. THE TRUTH TO THE MATTER IS...FORD DOES NOT CARE THAT A POTENTIALLY HIGH RISK PROBLEM HAS BEEN IDENTIFIED AS A FAILURE ON THE COMPANY'S END BUT THEY DON'T CARE ENOUGH TO DO ANYTHING ABOUT IT. WELL..OTHER THAN CHARGE THE CUSTOMER CLOSE TO $1000 OUT OF POCKET TO FIX FOR A POOR DESIGN ON FORD'S END. THE FORD DEALERSHIP SERVICE DEPARTMENT DOES NOT KNOW HOW THIS SAFETY FEATURE BROKE. IF WE WERE TO GET IN AN ACCIDENT WHILE THE AIRBAG IS IN THIS STATE, IT WOULD NOT DEPLOY AND THE LIVES OF ALL PASSENGERS IN JEOPARDY!
Dec 18, 2020
AIRBAG WARNING LIGHT APPEARED ON INSTRUMENT GAUGE @ APPROX 65,000 MILES. THE CONCERN IS FOR THE REAR SEAT RESTRAINT SYSTEMS THAT HAVE AIRBAGS BUILT INTO THE SEATBELT SHOULDER STRAPS. THIS DESIGN FLAW BY FORD MOTOR CO HAS RESULTED IN FAULTY WIRE HARNESS SYSTEMS FOR THE SEAT BELT AIRBAGS. FORD IS NOT TAKING ACTION BECAUSE THERE IS NO OFFICIAL "RECALL" EVEN THOUGH THIS IS A WELL KNOWN DESIGN DEFECT. FORD IS LEAVING THE RESPONSIBILITY UP TO CONSUMERS TO PAY OUT-OF-POCKET FOR THIS REPAIR @ A $660.00 COST!!! THIS IS ABSOLUTELY UNACCEPTABLE AS WE ARE TALKING ABOUT ARGUABLY THE MOST IMPORTANT SAFETY FEATURE OF A MODERN AUTOMOBILE...THE AIRBAGS!!! FORD CLEARLY CANNOT STAND BEHIND THEIR OWN PRODUCTS FROM A SAFETY STANDPOINT, SO CONSUMERS SUCH AS MYSELF ARE FORCED TO PAY THE $660.00 CHARGE IN ORDER TO PROTECT THE PASSENGERS (OFTEN CHILDREN IN OUR SCENARIO) IN THE BACKSEAT OR TAKE THE DEATHLY RISK OF SAFETY AIRBAGS NOT DEPLOYING IN AN ACCIDENT SCENARIO? YOU'VE GOT TO BE KIDDING ME. EXTREMELY SHAMEFUL AND DISAPPOINTING THAT ONE OF THE BIGGEST AUTOMOBILE MANUFACTURERS IN THE WORLD CANNOT STAND BEHIND IT'S OWN SAFETY PRODUCTS. THIS NEEDS TO BE ISSUED A RECALL PRONTO...THIS IS PEOPLE'S SAFETY WE ARE TALKING ABOUT HERE!
Oct 30, 2019
THE AIRBAG WARNING LIGHT HAS COME ON. IN TAKING THE CAR TO THE DEALERSHIP, THIS WAS TRACED BACK TO FORD'S ERROR CODE DTC B141B AND/OR B141C. THIS ERROR CODE HAS TO DO WITH FORD INSTALLING A DEFECTIVE WIRING HARNESS FOR THE REAR SEAT INFLATABLE AIRBAGS AND COULD CAUSE THEM TO FAIL TO OPERATE DURING A COLLISION. THE DEALERSHIP (SHEEHY FORD, MIDLOTHIAN, VA) REFUSES TO REPAIR THE VEHICLE. I ALSO CONTACTED FORD MOTOR COMPANY TWICE (5/29/19 AND IN APRIL 2019) AND THEY ALSO REFUSE TO REPAIR THE VEHICLE DESPITE IT BEING AN OBVIOUS SAFETY DEFECT THAT SHOULD BE COVERED UNDER THEIR SAFETY RESTRAINT WARRANTY. THE FACT THAT FORD IS REFUSING TO STAND BEHIND THE SAFETY OF THEIR VEHICLE HAS ME CONCERNED. *TR
May 29, 2019
UNKNOWN OR OTHER,VISIBILITY/WIPER
5 complaints
when traveling at highway speed the side fins fly off. i have had them replaced 3 times now at dealership. thank God there was not someone behind me - especially on a motor cycle it could of killed them
Nov 26, 2023
All of the moulding, seals & rubber windshield trim/gasket around the windshield has failed. It has cracked, broken off and much is now missing off the vehicle. Now when I drive the vehicle it makes scary noises due to the cracked/missing moulding/seals. This has created some scary driving situations that almost caused accidents while on highways. Now I worry my windshield will leak and damage the interior. This does not seem to be something that should be happening to my Ford Explorer and why isn't this a recall issue.
Nov 03, 2023
While driving on Freeway 10 on June 23, 2023 around the Palm Springs area the passenger windshield side panel flew off. There were considerable wind gusts while driving at average traffic speed around 70 mph. The driver windshield side panel flew off on June 2020 on the same freeway also during wind gusts. I fixed the driver side panel by ordering a replacement part and used additional epoxy reinforcement which proved more effective than just original affixing as the part still remains affixed in place.
Jun 23, 2023
The window trim/window pillars keep flying off on the interstate/highway!!! I’ve replaced them multiple times and yet continue to fly off !!!! PLEASE RECALL AND REPLACE THESE ON THE EXPLORERS ITS SAD !!!!
Jun 07, 2023
I was traveling on I 95 at around 55 to 60 mph when all of a sudden, the plastic trim on the side of the windshield the passenger side flew off cracked and started dangling over my passenger side window and mirror. The piece blocked my view of my mirror while I was traveling in the left lane approaching a left exit. I had to pull to the left shoulder because I was blinded by the piece on my right and could not see if the lanes were clear for me to go right. I put my hazards on and had to get out on I-95 and remove the hanging trim so I could see through my passenger mirror again. The piece probably would have become a flying object at highway speed endangering any motorist behind or beside me.
Apr 19, 2023
STRUCTURE,VISIBILITY/WIPER
4 complaints
Windshield seal flies out from under the pilar molding and smacks windshield and passenger window.
May 20, 2025
Driver A pillar molding flew off and hit the driver's mirror and driver's side window doing 70 mph. Amost resulting in a accident.
Jun 16, 2023
While driving at 55+mph both driver side and passenger side A-pillar windshield covers vibrate. Eventually the passenger side blew off during the drying cycle at a car wash. Thankfully it was contained and did not fly off on the road and cause an incident. There are more cases of this occurring on the highways as seen by searching the internet.
Jul 06, 2021
WHILE DRIVING ON INTERSTATE, THE WINDSHIELD MOLDING BECAME LOOSE AND STARTING VIBRATING. AFTER PULLING OVER AND ATTEMPTING TO SECURE, IT THEN BECAME PARTIALLY DETACHED AND WAS BENT BACKWARDS. IT OBSTRUCTED THE VIEW OF THE REAR VIEW MIRROR AND PASSENGER SIDE WINDOW. IT THEN FLEW OFF INTO ONCOMING TRAFFIC. LUCKILY, IT LANDED ON THE SHOULDER AND DID NOT HIT ANOTHER CAR/CAUSE A WRECK ON THE INTERSTATE. THE DRIVER SIDE IS ALSO PARTIALLY COMING OFF ACCORDING TO REPAIR QUOTE FROM DEALERSHIP.
Oct 05, 2018
STEERING,WHEELS
4 complaints
Other Explorers have a recall for electric steering problems but my VIN is not included in the recall. I only have 52,000 miles on the vehicle with clunking sounds when we back up with the wheels turn to the right. I also have had really bad tire wear on the back with the inside edge completely worn off. Toe in adjustment way off, says that this vehicle already had the fix for that but looks like it was not fixed right. We are still driving vehicle at this time but not sure if we should or not? We just had new tires put on vehicle and they checked for the clunking sound. There are no warning lamps on. I will be taking the vehicle to thr Ford dealer on October 23, 2024.
Oct 07, 2024
The rack and pinion steering has gone bad. This is causing the vehicle to be hard to drive as it is very difficult to turn the wheel and control the vehicle. This is making it dangerous to drive as you are unable to turn the wheel very well.
Feb 20, 2024
On February 03, 2022 I took my to the Ford dealership in my area, I was told that rear toe link was replaced. After 8 months while I was driving the Explorer 2016, the car starts swerving from side to side, and lost the control. For few seconds I was struggling to stop the car, after I stopped the car I checked the tires, I saw the rear left passenger tire was loosen, and steering wheel wasn’t straight. Me and my friend were terrified and still not feeling alright. I lost the confidence in Ford Explorer.
Oct 16, 2022
MY TIRE VALVE CORRODED AFTER 3 YEARS WITH THE CAR. WHICH CAUSED DAMAGE TO THE TIRE AND THE TIRE PRESSURE SENSOR. THE POWER STEERING WENT AT 67000 MILES. IT STOPPED WORKING COMPLETELY WHILE DRIVING, EXTREMELY SCARY. THE SERVICE DEPARTMENT AT THE DEALERSHIP SAID IT IS JUST SOMETHING THAT HAPPENS. $2400 FIX ON A 4 YEAR OLD CAR WITH 67000 MILES AND COULD HAVE CAUSED AN ACCIDENT.
Oct 02, 2020
ENGINE,ENGINE AND ENGINE COOLING
4 complaints
The at the engine is built the coolest is leaking into it. This causes the engine to seize while driving and is very dangerous. If you catch it early it’s an expensive fix if you catch it late it’s a new engine you’ll need/ there is no warning signs for it.
Apr 02, 2024
Driving on [XXX] when the engine began smoking (fogging) and I was unable to see. I stopped and could not go any further. Two cars nearly hit me. It took 10 minutes or longer for the car to cool down and the computer to allow me to move the vehicle 20' to get off the busiest street in Alabama. The car has 106,000 miles on it and the Ecoboost engine is blown. Ford refuses to do anything about it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Apr 02, 2024
Water pump leaking and needs to be replaced. Can cause engine failure and lead to being stranded on highway. Multiple forums have people with the same issue. No warning lights have come on. I took the vehicle in for another issue and they pointed out the leak to me.
Dec 11, 2023
Water pump failure, engine coolant leakage from water pump
Oct 13, 2023
STEERING,SERVICE BRAKES
4 complaints
Tires damaged due to a rear toe link not having proper alignment adjustments. I was told to buy aftermarket products because the two ASE certified shops could not align my rear suspension. I've chewed through two pairs of brand new tires in less than 4 months.
Sep 23, 2023
I have had a malfunction with what may be the front right break or steering component. Occasional metal on metal/grinding noise made when making a hard right turn or reversing left. Vehicle had been taken in a few times after purchase (Honda dealership), sound was duplicated but no issue detected by mechanics. Vehicle has been taken to ford and no issue detected. No warning lamps have ever come on.
Jul 19, 2023
TL* THE CONTACT OWNED A 2016 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 70 MPH, AN ABNORMAL NOISE WAS HEARD FROM THE FRONT OF THE VEHICLE. AFTER THE NOISE WAS HEARD, THE VEHICLE LOST STEERING AND BRAKE FUNCTIONALITY. AS A RESULT, THE CONTACT WAS INVOLVED IN A SIDE IMPACT COLLISION WITH THE MEDIAN WALL AND THE VEHICLE OVERTURNED. THE SIDE AIR BAGS DEPLOYED PRIOR TO THE CRASH. THE FAILURE OCCURRED WITHOUT WARNING. THE CONTACT AND HER DAUGHTER SUFFERED MODERATE BRUISING THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE INSURANCE COMPANY'S LOT AND DEEMED DESTROYED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 58,064.
Apr 02, 2018
ON OCT. 18 WHILE OPERATING AT HIGHWAY SPEED OF 40 MPH ON HWY. 301 SOUTH IN WILSON NC AND ATTEMPTING TO SLOW DOWN TO STOP FOR THE TRAFFIC STOPPED AT THE TRAFFIC LIGHT AHEAD THE BRAKE PEDAL AND STEERING BOTH DID NOT FUNCTION, I WAS UNABLE TO STOP OR STEER THE VEHICLE CAUSING A REAR-END COLLISION TO HIT THE VEHICLE IN FRONT OF MINE. MY VEHICLE WAS TOWED TO KENLY FORD LATER THAT DAY FROM THE ACCIDENT SITE WHERE IT WAS PURCHASED, THEY RAN CHECKS AND FOUND NO CODES. ALL I KNOW IS THE BRAKES AND STEERING DID NOT WORK.
Oct 26, 2016
POWER TRAIN,ELECTRICAL SYSTEM
4 complaints
94000 MILES THE TRANSFER CASE BURST AND WHEN 70000 MILES CHARGING CYCLE DOES NOT WORK , THE VEHICLE SUDDENLY STOPS.
Feb 22, 2021
POWER TRAIN CONTROL MODULE AND ENGINE CONTROL MODULE FAILED UNDER HIGH SPEED ON A 4 LANE ROAD. WE WERE ALMOST KILLED BY BEING REAR-ENDED TRAFFIC AS VEHICLE CAME TO A COMPLETE STOP, ENGINE OFF, AND COMPLETELY DEAD. NOT ABLE TO STEER OR BRAKE. VEHICLE HAS ONLY 12,854 ACTUAL MILES. PLEASE FIX THIS BEFORE OTHERS ARE KILLED AND/OR MAIMED.
Nov 17, 2017
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING 55 MPH, THE VEHICLE DECELERATED TO A COMPLETE STOP INDEPENDENTLY AND THE WRENCH WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 11,000.
Sep 13, 2016
WAS DRIVING ALONG BUSY ROAD MAKING A LEFT TURN AT RUSH HOUR ACROSS TWO LANES OF TRAFFIC. CAR SIMPLY DIED. NO RESPONSE TO ACCELERATOR. WRENCH LIGHT ON. I COULD HAVE BEEN HURT BADLY. WAS ABLE TO GET CAR OUT OF TRAFFIC. WAS TOLD THIS IS A SEVERE PROBLEM WITH THROTTLE BODY AND FORD IS AWARE OF THIS. CAR HAS LESS THAN 5100 MILES ON IT. THIS NEEDS TO BE A RECALL SITUATION.
Jun 16, 2016
POWER TRAIN,ELECTRICAL SYSTEM,ENGINE
4 complaints
WITHIN 10 DAYS OF BUYING IT BRAND NEW I'VE HAD ELECTRICAL PROBLEMS. REPLACED BACK UP SCREEN WITHIN THOSE 10 DAYS EVEN THOUGH THEY DIDN'T FIND ANYTHING WRONG. STILL CONTINUES. MULTIPLE ISSUES WITH THE POWER TRAIN. NOW I'VE BEEN OUT OF A CAR FOR 2 WEEKS BECAUSE I MIGHT NEED A NEW TRANSMISSION AT 65,000 NO LONGER UNDER WARRANTY. HOW CAN I PAY $38,000 AND IT GOES BAD INSTANTLY? NO HELP FROM FORD OR DEALER. MY GEARS ARE STALLING AND NOT SHIFTING CORRECTLY OR PICKING UP SPEED. I DRIVE LIKE AN OLD LADY AND TAKE CARE OF THIS CAR LIKE IT'S BRAND NEW. I WILL NEVER BUY A FORD AGAIN AND WILL TELL ANYONE WHO WILL LISTEN NOT TO DO THE SAME.
Nov 05, 2020
REQUIRED A NEW TRANSMISSION. REPORTED INITIAL PROBLEM AT 58,000 MILES THE DEALER COULD NOT FIND A PROBLEM WHILE CAR WAS STILL UNDER WARRANTY. CAR WAS EXPERIENCING A HESITATION DURING ACCELERATION. AT 80,000 MILES THE TRANSMISSION HAD TO BE REPLACE (OUT OF WARRANTY). REQUIRE NEW BATTERY AND CABLES AFTER BATTER "EXPLODED" CORRODING THE BATTERY CABLES. (68,000 MILES). REQUIRED A NEW WATER PUMP AT 86,000 MILES.
Aug 10, 2019
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE LOST POWER AND THE SERVICE "WRENCH" WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD AND WAS TOWED TO THE DEALER (NORTHTOWN FORD IN MENOMONIE, WI) WHERE THE THROTTLE BODY WAS REPLACED. THE FAILURE RECURRED AND THE SAME DEALER REPLACED THE RETAINING CLIP, BUT THE FAILURE RECURRED. THE CONTACT MADE THE MANUFACTURER AWARE OF THE FAILURES AND REQUESTED A BUY-BACK. THE CONTACT WAS INFORMED THAT THE ISSUES DID NOT WARRANT A BUY-BACK. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 9,000.
Aug 07, 2017
2016 FORD EXPLORER SHUTS OFF WHILE DRIVING. IT'S A KNOWN ISSUE, BUT THE VEHICLES ARE STILL BEING SOLD AND NO RECALL OR SYSTEMATIC WAY OF REPLACING IT. I WAS ON THE HIGHWAY AND THE VEHICLE JUST SLOWED DOWN TO A CRAWL TWICE. FORD OFFER NO SOLUTION. I CHECKED ONLINE AND THIS SEEMS TO BE A PROBLEM MANY PEOPLE ARE EXPERIENCING. I ALMOST GOT HIT TWICE TRYING TO GET TO THE SHOULDER LANE.
Aug 01, 2016
STRUCTURE,UNKNOWN OR OTHER,ENGINE
4 complaints
STRONG EXHAUST AND VERY HIGH LEVELS OF CO ENTERING CABIN AT NORMAL ACCELERATION, VERY BAD AT HARD ACCELERATION I HAVE MULTIPLE PICTURES OF MY CO SENSOR I HAD IN THE VEHICLE FOR SOME TIME NOW WITH LETHAL CO LEVELS. I BELIEVE THE EXHAUST MANIFOLDS HAVE BIG ENOUGH CRACKS TO FLOOD IN CO INTO THE CABIN THROUGH OPENINGS. MINE HAS HAD THE 'DEALER ITSB' TO RESOLVE, NO CHANGE AND IT REGISTERED HIGHER AFTER. REPLACE THIS MANIFOLD AND SEAL THIS TRUCK OR BUY IT BACK FROM ME FORD. IF PUTTING MY FAMILY'S LIFE IN DANGER DAILY DOESN'T SCARE YOU, THE PICTURES AND PROOF I HAVE ARE ENOUGH FOR ANOTHER LAWSUIT AGAINST YOU FOR THIS! I NEED TO BE CONTACTED BY A FORD REP (NOT A DEALERSHIP) TO RESOLVE OR MY LAWYERS WILL FOLLOW UP WITH YOU. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *PM
Sep 09, 2018
I ALREADY SUBMITTED ONE COMPLAINT TODAY ABOUT THE CABIN FILLING WITH EXHAUST FUMES WHILE ACCELERATING BUT THEN I WAS READING OTHER ISSUES PEOPLE WERE HAVING AND WANTED TO ENSURE YOU WERE AWARE OF MINE AS WELL. I HAD TO HAVE THE COOLING FANS REPLACED BECAUSE THEY WOULD COME TO A SCREECHING HALT WHEN YOU WOULD SHUT THE MOTOR OFF. I HAD TO HAVE THE INSIDE OF THE POWER LIFT GATE REPAINTED WHERE THE MOTOR AND SHOCK ARE LOCATED BECAUSE THE PAINT WAS CRACKING. THE CENTER CAPS ON THE WHEELS ARE FALLING IN SO THOSE ARE GOING TO BE REPLACED. IT IS NOW RUSTING ON THE BACK OF MY CAR BY THE REAR TAIL LIGHT. THE HOOD VIBRATES REALLY BAD WHEN GOING OVER 65 MPH. I HAVEN'T TAKEN IT IN FOR THAT YET BECAUSE I CAN'T GET IT TO DO IT ALL OF THE TIME. IT HAS TO BE WINDY FOR IT TO HAPPEN TO ME. THE FRONT DOOR BLACK TRIM PIECES ON THE OUTSIDE STARTED TO BUBBLE SO THOSE HAD TO BE REPLACED. THE ONLY SAFETY CONCERN IS THE HOOD VIBRATING. THE REST ARE JUST FYI'S AS THEY SEEM TO BE COMMON PROBLEMS. I BOUGHT THIS CAR BRAND NEW IN NOVEMBER 2015 AND IT HAS HAD PROBLEMS SINCE THE 1ST MONTH.
Feb 21, 2017
WE TOOK OUR 2016 EXPLORER LIMITED BACK TO THE SHOP FOR THE SECOND TIME AFTER SMELLING EXHAUST IN THE CABIN AGAIN WHILE IN OPERATION. DURING THE FIRST VISIT THE DEALER BEGAN DISCUSSING THE FORD REPAIR BULLETIN THAT CAME OUT 30 DAYS OR SO AGO THAT WAS TO FIX THE EXHAUST LEAK. HOWEVER, AFTER A COUPLE OF HOURS LATER WE RECEIVED A CALL THAT THE BULLETIN HE REFERENCED WAS SPECIFICALLY FOR 2011 THRU 2015". WE WERE TOLD THAT PER THE BULLETIN THE EXHAUST SYSTEM FROM THE ENGINE MANIFOLD TO THE TAIL PIPE GETS REPLACED, A FRESH AIR VENT NEAR THE REAR OF THE VEHICLE GETS "RE-ROUTED" AND THE BUMPER COMES OFF TO GAIN ACCESS TO SOME METAL SEAMS NEEDED TO BE FILLED. OUR SERVICE REPRESENTATIVE STATED HIS HANDS WERE TIED AND COULD NOT DO ANYTHING MORE THAN TAKE IT IN A CHECK IT OUT. THEY CALLED A FOUND THE EXHAUST OUTLETS WERE RECESSED TOO FAR INTO THE BUMPER AND RESET THEM TO THE ORIGINAL POSITION. WE PICKED IT UP MONDAY AND THEN DRIVING IT TUESDAY THIS WEEK A HORRIBLE SMELL CAME TOR THE CABIN AND TOOK MY BREATH AWAY. BLACK SMOKE WAS COMING OUT OF THE EXHAUST PIPE. WE TOOK IT BACK TO THE DEALER YESTERDAY.
Feb 08, 2017
I HAVE TO MAJOR COMPLAINTS WITH THE FORD EXPLORER 2016. THE TRUCK WAS PURCHASED BRAND NEW. THE FIRST OCCURRED WHEN I WAS ON MY WAY TO WORK ABOUT 7:30AM. I WAS DRIVING ABOUT 60 MILES PER ON HOUR ON A CITY STREET AND ALL OF A SUDDEN A WRENCH SYMBOL SHOWS AND THE CAR WILL NOT ACCELERATE ANYMORE. I HAD NEVER SEEN THIS SYMBOL BEFORE SO I WASN'T SURE WHAT WAS GOING ON AND COULD NOT FIND IT IN THE MANUAL. BEFORE THIS I ONLY COULD GO ABOUT 5 MILES PER HOUR MAX SPEED. WHEN I GOOGLED THE WRENCH MANY OTHERS HAD THE SAME ISSUE. I AM SURE FORD IS AWARE OF THIS AND SHOULD HAD SAID SOMETHING ABOUT THIS BEFORE WE PURCHASED IT. I HAD TO END UP LEAVING THE EXPLORER UP AT FORD FOR 2 AND A HALF WEEKS. WHEN I GOOGLED THE ISSUE IT SAID THESE EXPLORERS HAVE A FAULTY THROTTLE BODY THAT HAS TO BE REPLACED AND MY VEHICLE WAS NO DIFFERENT. ME AND MY WIFE SHOULDN'T HAVE TO MAKE MONTHLY PAYMENTS ON A BRAND NEW VEHICLE THAT HAS A KNOWN ISSUE. SECONDLY, ONCE WE HIT ABOUT 8,000 MILES THE HOOD MAKES A LOUD BUZZING/HUMMING SOUND ONCE YOU HIT ABOUT 60 MILES PER HOUR THAT DOES NOT STOP!!! MANY OTHER PEOPLE WITH THIS VEHICLE HAVE THE SAME PROBLEM ONCE I GOOGLED THIS! THIS IS ABSOLUTELY RIDICULOUS. THIS VEHICLE SHOULD BE RECALLED AND NOT SOLD! OUR ENTIRE TRIP THIS VEHICLE MADE THE SOUND NONSTOP. A PERSON SHOULD NOT HAVE TO HEAR THIS THE ENTIRE TIME ON A BRAND NEW VEHICLE THAT YOU MAKE MONTHLY PAYMENTS ON. SOMETHING SHOULD BE DONE ABOUT THIS. SINCE FORD DOES NOT WANT TO VOLUNTARILY ISSUE A RECALL LIKE THEY SHOULD, AN INVOLUNTARY RECALL SHOULD BE ISSUED. WHEN I GOOGLED THIS, IT IS SAID THAT THE SOUND COMES FROM THE THIN PART OF THE HOOD IN THE CENTER THAT IS BETWEEN TWO THICKER PIECES THAT CAUSES IT TO VIBRATE. HORRIBLE DESIGN AND SHOULD HAVE BEEN TESTED BETTER.
Jul 31, 2016
VEHICLE SPEED CONTROL,ENGINE,FUEL/PROPULSION SYSTEM
4 complaints
2016 FORD EXPLORER ACCELERATES WHILE DRIVING. MY VEHICLE HAS BEEN IN AND OUT OF DEALERSHIP SINCE 12/26/17. I AM CURRENTLY IN A LOANER VEHICLE. RECEIVE UPDATE FIRST WEEK OF FEB 2018 THAT THE TRANSMISSION DEPT WAS BEHIND AND THAT THEY WILL LET ME KNOW AS SOON AS POSSIBLE IF I NEED A NEW TRANSMISSION.
Feb 13, 2018
VEHICLE LOST POWER WHILE DRIVING DOWN A BUSY HIGHWAY AT 65+ MPH. ENGINE WAS RUNNING ROUGH (SOUNDED LIKE A TRACTOR) AND COULD NOT ACCELERATE. DASH LIGHTS CAME ON. VEHICLE WAS ABLE TO COAST TO AN EXIT RAMP WHERE IT WAS TOWED TO THE DEALERSHIP TO HAVE THE THROTTLE BODY REPLACED. MILEAGE WAS JUST OVER 7,000. IT IS SAD THAT I HAD TO RESCUE MY FAMILY (WIFE, 4 MONTH OLD BABY, 3 YEAR OLD AND 6 YEAR OLD) OFF A BUSY HIGHWAY EXIT RAMP WHEN THE VEHICLE IS LESS THAN 6 MONTHS OLD. THE TOW TRUCK DRIVER SAID HE GETS ABOUT 3 OR 4 OF THE SAME ISSUE WITH NEW EXPLORERS A WEEK. HOW CAN THIS NOT BE A RECALL? NOW WE WILL DRIVE IN FEAR OF THIS PROBLEM OCCURRING AGAIN SINCE, FROM WHAT THE DEALER SAID, THE THROTTLE BODY WAS REPLACED WITH THE EXACT SAME PART. I GUESS WE JUST WON'T TAKE ANY LONG TRIPS WHEN WE ARE AROUND 7,000 MILES ON THIS THROTTLE BODY...? UNBELIEVABLE FORD. WHAT A PIECE OF JUNK!
Aug 25, 2016
THIS PARTICULAR PROBLEM OCCURRED THREE TIMES OVER TWO DAYS. THE FIRST TIME I WAS DRIVING APPROXIMATELY 45MPH ON A CITY STREET WHEN A WRENCH LIGHT AND AIRBAG LIGHT CAME ON AND THE VEHICLE'S THROTTLE STOPPED RESPONDING. IF I LET OFF THE BREAK THE VEHICLE WOULD CONTINUE TO MOVE AT APPROXIMATELY 5MPH SO I WAS ABLE TO GET IT OFF THE ROADWAY. I TURNED THE VEHICLE OFF AND BACK ON AND IT SEEMED TO BE FUNCTIONING NORMALLY WITH THE CHECK ENGINE LIGHT ILLUMINATED. I WAS ABLE TO MAKE IT TO MY OFFICE WHERE I LEFT IT PARKED UNTIL AFTER LUNCH. WHEN I CRANKED UP THE VEHICLE AFTER LUNCH THE CHECK ENGINE LIGHT WAS NO LONGER ON. AFTER DRIVING APPROXIMATELY TEN MORE MILES I ATTEMPTED TO MAKE A LEFT TURN INTO A PARKING LOT WHEN THE SAME THING HAPPENED AND I WAS ALMOST HIT BY AN ONCOMING TRUCK. AFTER TURNING THE VEHICLE OFF FOR A WHILE I CRANKED IT AGAIN AND THE CHECK ENGINE LIGHT WAS NOT ILLUMINATED. I MADE IT HOME WITH NO ISSUE AND THE NEXT MORNING I LEFT HOME HEADING TO THE DEALERSHIP TO DROP THE VEHICLE OFF. AS I WAS TURNING LEFT ON TO A SIDE STREET THE VEHICLE AGAIN STALLED AND AGAIN I WAS ALMOST STRUCK BY ONCOMING TRAFFIC. I TURNED THE VEHICLE OFF AND BACK ON AND AFTER THAT WAS ABLE TO MAKE IT TO THE DEALERSHIP WITHOUT AN ISSUE. THE DIAGNOSTIC TEST INDICATED THAT THE ELECTRONIC THROTTLE BODY WAS THE ISSUE. THE DEALERSHIP INFORMED ME THAT THIS WAS A WIDESPREAD PROBLEM. THE VEHICLE I WAS OPERATING IS AN UNDERCOVER POLICE VEHICLE AND ONLY HAS 9,000 MILES ON IT. HAD I BEEN RESPONDING TO AN EMERGENCY AT A HIGH SPEED I FEAR THAT EITHER I OR ANOTHER MOTORIST COULD HAVE BEEN SERIOUSLY HURT OR KILLED.
Jul 07, 2016
I WAS DRIVING HOME AT 10:00 AM AFTER VISITING A DOCTOR'S OFFICE ON A BUSY HIGHWAY AT 57 MPH WHEN ALL OF A SUDDEN THE CAR GAS PEDDLE IS NOT WORKING. THE CAR IS IN COMPLETE SHUT DOWN MODE. I ROLLED THROUGH AN INTERSECTION TO GET TO SAFE PLACE OUT OF TRAFFIC. THE CAR DASH BOARD SHOWED A WRENCH AND ENGINE LIGHT AND ON THE DASHBOARD A MESSAGE STATED "SEE MANUAL". THE CAR HAD COMPLETELY SHUT DOWN. SCARED TO DEATH AT WHAT JUST HAPPENED, I CALLED FORD WARRANTY NUMBER FOR A TOW TRUCK AND WAITED FOR 2 1/2 HOURS TILL FINALLY THE TOW TRUCK SHOWED UP. WHEN I GOT TO THE DEALERSHIP WHERE I PURCHASED THE CAR, I WAS SERIOUSLY DEVASTATED. TWO MANAGERS TOLD ME THEY DIDN'T KNOW WHAT WAS WRONG WITH THE CAR, BUT THEY WOULD WORK TO FIND OUT. THEY KNEW WHAT THE PROBLEM WAS AND HOW SERIOUS THIS SITUATION WAS AND NEVER TOLD ME AT THE TIME. I SEARCHED THE INTERNET AND FOUND THAT THE PROBLEM IS THE THROTTLE BODY. IT HAS BEEN HAPPENING A QUITE A FEW OF FORD'S CARS. I STILL CAN'T BELIEVE THE VERY SERIOUS SITUATION I HAD BEEN IN. I SEARCHED TO SEE IF THERE WERE ANY RECALLS FOR MY VEHICLE AND THERE WASN'T ANY. THIS NEEDS TO STOP AND FORD NEEDS TO RECALL ALL THESE VEHICLES BEFORE SOMEBODY GETS KILLED. I DO NOT CARE TO OWN THIS VEHICLE ANY LONGER OR ANY OTHER FORD VEHICLE FOR THAT MATTER.. WHOSE TO SAY THIS PROBLEM DOESN'T EXIST IN ANY OTHER MODELS. I WAS CALLED YESTERDAY BUT JUSTIN IN SERVICE AND WAS TOLD THAT IT IS THE THROTTLE BODY AND IT WAS GOING TO TAKE ALONG TIME TO GET THE PART AND THAT HE WOULD STAY IN TOUCH TO LET ME KNOW ANYTHING. HE STATED THAT SAM GALLAWAY FORD WOULD PAY FOR THE 1ST 9 DAYS OF MY RENTAL AND THEN MY INSURANCE WOULD HAVE TO PAY THE REST.
Jun 28, 2016
BACK OVER PREVENTION
3 complaints
The contact owns a 2016 Ford Explorer. The contact stated that while reversing, the back-over prevention camera screen was distorted. In addition, the contact stated that the screen image was wavy and had several colors. The dealer was made aware of the failure. The contact was informed of an unknown recall with a similar failure description; however, the contact was informed that the VIN was not associated with the recall. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 107,929.
Oct 15, 2025
The contact owns a 2016 Ford Explorer. The contact’s spouse stated that while reversing, the rearview camera image was distorted, nearly causing the driver to hit a child while reversing in a parking lot. A bystander alerted the driver to stop the vehicle, which prevented the incident from occurring. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 116,000.
Aug 07, 2025
The contact owns a 2016 Ford Explorer. The contact stated that while reversing the vehicle, the back over prevention camera malfunctioned and failed to display an image. The contact stated that the message "rear camera not available" was displayed. Additionally, the contact stated that the front driver’s side and passenger’s side window trim molding became unsecured and might detach from the vehicle. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was 89,320.
May 09, 2023
ELECTRICAL SYSTEM,UNKNOWN OR OTHER
3 complaints
The rear camera, mounted on the lift gate, is no longer operating correctly. At times, it will flicker off and on, camera picture 'rolls', or does not work at all (black screen with error message - "camera is no longer operational, contact the dealership"). These incidents with the camera have occurred multiple times each month over the last year. When reversing in the dark especially, this becomes a major safety issue. Currently do not see a NHTSA or Ford recall for this defect.
Jul 03, 2025
DASH/SPEEDOMETER WENT BLACK - HEAT AND AIR SYSTEM INOPERABLE - NO TURN SIGNALS - POWER DECREASED AND POWER STEERING NOT FULLY FUNCTIONING. ALL OF THIS HAPPENED WHEN I PLACED THE CAR IN PARK AND REALIZED THE RADIO AND INTERIOR LIGHTS WERE NOT AUTOMATICALLY SHUTTING OFF SO I RESTARTED THE CAR AND STILL NOTHING. DEALERSHIP RECOMMENDED DISCONNECTING THE BATTERY - THIS DID FIX PART OF THE PROBLEMS BUT THE SYNCH HEALTH REPORT IS STILL NOT SHOWING COMPLETLELY CLEAR AND THE CHECK ENGINE LIGHT CAME ON THEN WENT OFF AFTER DRIVING A FEW MILES . CONCERNED IF IT IS SAFE TO DRIVE ESPECIALLY IF THIS IS A POSSIBLE ELECTRICAL PROBLEM - CAR IS JUST AT 23K MILES AND ALSO HAD TO HAVE THROTTLE BODY REPLACED AT AROUD ONLY 3K MILES. NOT FELING SAFE IN THE CAR AT THIS POINT.
Apr 02, 2018
WITH ONLY 3.9 K MILES THE VEHICLE STOPPED ACCELERATION AND TURNED OFF. I WAS ABLE TO TURN THE CAR ON, HOWEVER, THE VEHICLE WOULD ONLY MOVE AT IDLE SPEED WHILE IN DRIVE. FORTUNATELY I HAD ENOUGH TO IDLE MY WAY TO THE SIDE OF THE ROAD. THE PART THAT WENT OUT WAS THE THROTTLE BODY. ALTHOUGH THE MANUFACTURER REPLACED THE PART ON THE VEHICLE, I FEEL THAT THEY HAVE BEEN VERY IRRESPONSIBLE IN NOT RECALLING THIS PART AND ADVISING BUYERS THAT THE CAR HAS A "FAULTY" THROTTLE BODY. EVERYONE AT FORD THAT I HAVE SPOKE TO ALMOST IMMEDIATELY KNEW WHAT THE ISSUE LEADING ME TO BELIEVE THAT I AM NOT THE ONLY PERSON THAT HAS HAD THIS ISSUE. THIS ISSUE COULD HAVE CAUSED A SEVERE ACCIDENT IF THE CAR WOULD HAVE SHUT OFF OR DE-CCELERATED WHILE DRIVING AT A HIGH RATE OF SPEED.
Jul 15, 2016
STEERING,ENGINE
3 complaints
Water pump
Mar 27, 2025
With less than 75k miles, the steering began to grind when turning. We had to get an entirely new rack and pinion unit replaced for over $2400. Thousands of 2016 Explorers have reported this problem but it is still not been deemed a recall. Recently, at 84K miles, the clutch on the AC compressor went out causing a $720 bill for a new compressor. We have also just found out the water pump is now bad and appears to be defective. In fact there was a class action lawsuit in 2020 regarding these defective pumps but this wonderful government we pay exorbitant taxes to, threw the case out on technicalities. Absolutely shameful.
Jul 06, 2021
I WAS DRIVING ON A MAJOR HIGHWAY HOME FROM WORK WITH NORMAL TRAFFIC. MY SPEED WAS APPROX 60-64 OR SO. WHILE IN LEFT LANE TRAVELING EAST --WITHOUT WARNING , MY ENGINE COMPLETELY SHUT OFF. IT WAS SO HARD TO STEER MY CAR -- I NEEDED TO WEDGE MY FOOT NEAR WINDOW /DRIVER DOOR TO GAIN LEVERAGE -AND WITH BOTH HANDS STEER THE CAR ( WHILE DECELERATING DOWN T O15 MPH) TO THE SHOULDER ON THE RIGHT SIDE. ALL DRIVERS PASSING ME - WITNESSED I WAS IN DIRE TROUBLE. I WAS ABLE TO GET TO SHOULDER AND PRAYED . MY REP AT QUEENS FORD WAS VERY HELPFUL AND I VE THANKED HIM NUMEROUS TIMES IN HIS ATTEMPTS TO HELP ME .BACK TO STORY: I OPENED THE HOOD , NO SMOKE -- MAYBE RADIATOR- SO I WAITED 10 MINUTES .THE ENGINE STARTED , I GOT BACK ON HIGHWAY-- AND IT SHUT OFF FOR A 2ND TIME. AT THAT TIME -- I WAS TOTALLY AFRAID TO DRIVE THIS CAR ANY FURTHER. MY QUEENS REP SUGGESTED GOING TO SYOSSET FORD WHICH WAS CLOSER AND I DID SO.IT TOOK ME WHAT FELT LIKE DAYS TO GET UP ENOUGH NERVE TO DRIVE THIS VEHICLE ANY FURTHER.I BELIEVE MY CASE HAS MANY SAFETY ISSUES AND I EVEN STATED TO FORD TAKE CAR BACK AND REPLENISH ME FOR LOSS OF INCOME / RENTAL FEES PAID DURING THE 7 DAY ORDEAL. PROBLEM WAS : THROTTLE BODY PART. I WASN'T THE ONLY PERSON WHO HAD COME IN WITH THIS PROBLEM . FORD IS VERY COGNIZANT ABOUT SUCH . I ASKED THEM THIS VEHICLE BACK ( HAS 5910 MILES ) ON IT AND PUT ME INTO ANOTHER LINCOLN PRODUCT WHICH IS SIMILAR. NOR HAVE THE ADDITIONAL MEANS TO RENT ANOTHER CAR.I WILL NEVER PURCHASE ANOTHER VEHICLE FROM FORD EVER. IF YOU CAN ASSIST ME TO ALERT OTHERS - FANTASTIC. OH , ADDITIONALLY, I OWNED A 2003 LINCOLN NAVIGATOR WHICH CONSTANTLY HAD ISSUES - AND THEY ( FORD /LINCOLN ) TOOK THAT VEHICLE IN UNDER NYS LEMON LAW -AND PROVIDED ME A NEW 2004 NAVIGATOR FOR NO COST AT ALL. DUE TO THAT EFFORT FROM FORD/LINCOLN . IVE BOUGHT 4 MORE FORD SINCE THEN . I SHOWED MY LOYALTY TO THEM , WHERE IS FORD'S .
Jun 02, 2016
ENGINE AND ENGINE COOLING,POWER TRAIN
3 complaints
The contact owns a 2016 Ford Explorer. The contact stated that while driving at various speeds, the engine overheated with the temperature gauge indicating that the engine was hot(H). The vehicle was taken to an independent mechanic where the water pump was replaced. The contact stated that several months later while in reverse(R), the vehicle failed to accelerate while depressing the accelerator pedal. There was no warning light illuminated. The vehicle was towed to the dealer for a diagnostic test and remained with the dealer for months. The contact was informed that the vehicle had failed to accelerate while in drive(D) or reverse(R). The dealer later diagnosed the vehicle with transmission failure and the contact was provided an estimate for the repair. The manufacturer was notified of the failure and the contact was provided a case number. The vehicle was towed to an independent mechanic where it remained unrepaired. The failure mileage was approximately 102,000.
Mar 05, 2025
The contact owns a 2016 Ford Explorer. The contact stated that the vehicle jerked while shifting into gear. The contact stated that upon shifting to drive(D) on several occasions, the vehicle failed to respond. There was no warning light illuminated. The vehicle was taken to the dealer, where the transmission was replaced. Additionally, the contact stated while driving 25 MPH, the vehicle shuddered, overheated, and stalled. There was no warning light illuminated. The contact was able to pull to the side of the road. The vehicle failed to restart and was towed to the residence, where a mobile independent mechanic diagnosed that the head gasket was blown. The vehicle was not repaired. The dealer was notified of the failure, but no assistance was provided. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 50,000.
Dec 20, 2024
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHEN THE VEHICLE WAS PLACED INTO REVERSE, IT JERKED. THE VEHICLE WAS TAKEN TO WOODY ANDERSON FORD (2500 JORDAN LN NW, HUNTSVILLE, AL 35810, (877) 315-0514) TO BE DIAGNOSED AND REPAIRED PER AN UNKNOWN RECALL REGARDING CARBON MONOXIDE. PRIOR TO TAKING THE VEHICLE TO THE DEALER, THE CONTACT BECAME VERY SLEEPY WHILE DRIVING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 77,000.
Apr 16, 2019
VISIBILITY,UNKNOWN OR OTHER
3 complaints
The moonroof malfunctions and can be stuck in the open position. The drain plug for the moonroof can easily get clogged causing water to back up into the overhead structure. This causes water to fall onto the driver and passengers. The water flows from the overhead area, the side pillars and onto the floorboards. The electrical components are then compromised and the motor that controls the moonroof stops working. In my situation my moonroof was stuck in the open position for several days. I live in Florida where it rains alot. It is not safe to drive with an open moon roof during a severe thunderstorm. In doing my research this seems to be a very common problem with Ford moonroofs. I've had to have it fixed twice now. Luckily the first time it was stuck in the open position but water continued to pour into the interior of my vehicle while I was driving. This caused me to be distracted as I was driving. I had it repaired both times at a Ford dealership
Jan 08, 2025
/EMPLOYEE STARTED THE CAR TO WARM IT UP AND THE BACK WINDOW EXPLODED. HAD TO HAVE BACK WINDOW REPLACED. VEHICLE HAD BEEN PARKED OVERNIGHT IN HIS DRIVEWAY. *TR
Jun 05, 2020
EMPLOYEE WAS DRIVING HOME FROM WORK. HE HAD WARMED UP HIS CAR BEFORE DRIVING ABOUT 10 MINUTES. ALL OF A SUDDEN HIS BACK WINDOW EXPLODED. WEATHER WAS COLDER. FOUND ONLINE THAT THERE WAS A PROBLEM WITH FORD'S WINDOWS HAVING ISSUES WITH WINDOWS GETTING TOO HOT AND THEN POPPING WHEN THE COLD AIR SURROUNDED IT.. *TR
Jun 05, 2020
SUSPENSION,POWER TRAIN,ENGINE
3 complaints
The contact owns a 2016 Ford Explorer. The contact stated that while driving at various speeds, the check engine warning light illuminated, and the vehicle failed to properly accelerate while depressing the accelerator pedal. The vehicle was taken to the local mechanic who diagnosed that oil from the turbo booster had leaked onto the catalytic converter and both the turbo booster and catalytic converter needed to be replaced. The vehicle was not yet repaired. The contact indicated that previously the power transfer off unit was faulty, causing the vehicle to suddenly lose accelerating power; and the front control arms and ball joints were replaced. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 85,000.
Oct 23, 2024
My car has 84000 miles on it. The car recently over heated, I checked the coolant level, and it was low. I filled it to the required level and the warning went away. 2 weeks later it came back, I brought it to the mechanic and was told that the engine needs to be replaced. That it is recycling exhaust from the engine back through the coolant system and that cylinder 3 is misfiring. I spent over an hour on the phone with Ford who repeatedly stiff armed me on any sort of assistance with the issue or information on expected or estimated failure rates for these issues. The car is currently at the mechanic where I have an estimate with a $12,000 price tag on it. To make this worse, in October of last year I was driving down [XXX] and when I went to exit the highway, there was a loud clunk and the car revved up real high before it started to move. This put me and all the drivers exiting this very busy off ramp in danger. At 74,000 miles I needed a new transmission because that loud clunk was me losing actual gears in the transmission. That repair cost right around $10,000 and again, Ford does not care. There were no warning lights with this issue, it just happened and left me in a very precarious predicament at a very busy intersection. The transmission has since been replaced for roughly a $10,000 price tag and now I am looking at another $12,000. All I want is Ford to do what is right. I could have been killed in that intersection or my car could have caught on fire recently with the engine issue. The financial strain of having to do 2 major repairs on a car that is relatively new and only had 74,000 for the transmission and 84,000 for the engine is unbelievable and unacceptable. Through research I feel that this transmission issue should be covered under an extension of the Customer Satisfaction Program #20B27 or #20N07 as the transmission issue fits the descriptions nearly perfectly. Built "Ford Tough" is apparently just a sales pitch. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
May 16, 2024
AS I WAS DRIVING MY 2016 FORD EXPLORER ON THE HIGHWAY ON 08/01/2019 I EXPERIENCED THE VEHICLE START TO STUTTER JUST BEFORE I WAS GOING ON TO THE ON RAMP MERGING ON THE HIGHWAY AND AFTER I WAS ON THE HIGH WAY THE VEHICLE STARTED SMOKING FROM UNDER THE HOOD AND WOULD NO LONGER ACCELERATE AND I COULD SMELL OIL BURNING AND PULLED OVER AND SHUT THE CAR OFF LOOKED UNDER THE CAR AND SAW THE PILE OF OIL UNDERNEATH BUT THE VEHICLE DID NOT HAVE THE ANY CHECK ENGINE LIGHT OR WARNINGS ONCE WE TOWED THE VEHICLE HOME I LOOKED UNDER THE CAR AND SAW THAT THE TRANSMISSION CASING WAS CRACKED PRETTY MUCH IN HALF I COULD ACTUALLY SEE THE GEARS INSIDE THE CASING OF THE TRANSMISSION I ALSO REMEMBERD IN THE PAST YEAR OR SO THE VEHICLE WOULD SHIFT VERY HARD AFTER BRAKING AND THEN GETTING BACK ON THE GAS IT HAPPENED EVERY ONCE IN A WHILE .
Aug 01, 2019
ELECTRICAL SYSTEM,SEATS
3 complaints
The contact owns a 2016 Ford Explorer. The contact stated that on several occasions while driving at various speeds, the air bag warning light illuminated. The vehicle was taken to a dealer where it was diagnosed that the second-row seat wiring harness plugs were damaged and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 109,000.
Apr 10, 2024
SEAT HEAT UNDER DRIVER SEAT KEEPS GOING BAD. ONLY THE SEAT BOTTOM, NOT THE TOP. I NOTICED AS THIS IS THE 3RD TIME IT HAS BEEN IN FOR THIS, THAT WHEN I HAVE THE SEAT IN THE FARTHEST BACK POSITION IT WORKS, BUT WHEN THE SEAT IS MOVED FURTHER IT PULLS ON THE WIRES. I WONDER IF THIS COULD BE CAUSING A SHORT IN THE WIRING, WHICH POTENTIAL COULD BE A FIRE HAZARD.
Feb 18, 2020
WHILE I WAS SITTING IN THE DRIVER'S SEAT OF MY RENTAL (THE VEHICLE RUNNING AND IN PARK), I PRESSED #2 OF THE NUMBERED BUTTONS, NEXT TO THE LOCK CONTROLS, AND THE SEAT STARTED MOVING BY ITSELF. THE SEAT MOVED UP AND FORWARD, WHILE THE STEERING WHEEL MOVED DOWN. MY LEGS STARTED TO GET COMPRESSED BY THE STEERING WHEEL, WHILE AT THE SAME TIME MY KNEES WERE BEING FORCED INTO THE PLASTIC PIECES UNDER THE STEERING COLUMN. MY BODY WAS BEING FORCED AGAINST THE STEERING WHEEL. I TRIED TO STOP THE SEAT FROM MOVING BY USING MY BODY TO CREATE A FORCE BUT THE SEAT WOULD NOT STOP. WHEN THE SEAT FINALLY STOPPED, MY LEGS WERE IN PAIN AND I COULD BARELY BREATHE FROM THE STEERING WHEEL BEING AGAINST MY CHEST. I PANICKED AND DIDN'T KNOW WHAT TO DO. MY HUSBAND HAD TO OPEN THE DRIVERS SIDE DOOR AND USE THE CONTROLS TO GET ME FREE. I WAS AFRAID FOR MY LIFE, I COULD'VE BEEN SEVERELY INJURED. IF MY HUSBAND WERE THE ONE TO PRESS THE BUTTON WHILE HE WAS SITTING IN THE DRIVERS SEAT, HE WOULD HAVE BROKEN BONES. MY RENTAL PROVIDER NEVER SHOWED US THE FEATURES OF THE VEHICLE, NOR WERE THERE ANY WRITTEN WARNING LABELS IN CLEAR SIGHT ON THE INSIDE OF THE VEHICLE. MY HUSBAND INFORMED ME AFTER THE INCIDENT THAT THE NUMBERED BUTTONS ON THE DOOR ARE A MEMORY FUNCTION FOR THE SEAT. IT IS NOW A STRONG FEAR OF MINE THAT IF I WERE DRIVING THIS VEHICLE, AND I ACCIDENTALLY PRESSED THIS BUTTON (THINKING I PRESSED THE LOCK CONTROL),THAT I WOULD BE IN A CAR ACCIDENT. THE DESIGN OF THIS MEMORY FUNCTION IS FLAWED AND NEEDS TO BE CORRECTED IMMEDIATELY BEFORE SOMEONE GETS SEVERELY INJURED OR KILLED. I AM ALSO FEARFUL THAT THE RENTAL COMPANY WILL RENT THIS VEHICLE TO SOMEONE ELSE, BECAUSE A LARGER PERSON THAN MYSELF, WILL UNDOUBTEDLY BE INJURED OR KILLED. WHETHER THIS IS A FACTORY PRESET OR A FUNCTION THAT HAD BEEN PROGRAMMED BY A PREVIOUS RENTER OR THE RENTAL COMPANY, I AM UNAWARE, BUT IT NEEDS TO BE ADDRESSED.
Nov 21, 2015
STEERING,SUSPENSION,WHEELS
3 complaints
I [XXX] went with my mom [XXX] to buy a vehicle off of [XXX] . It was a 2016 ford explorer. I payed 13,000. The began to lose control when driving on a bumpy road and while braking I took the car to a Ford dealer and had some repairs, but they didn’t find the problem. I used the car sparingly and within two weeks it got much worse. Very unsafe to drive I brought it to another Ford dealership and I paid for substantial repairs for the suspension. The first time I drove it on a bumpy the car lost control again. I managed to regain control and drive it to the side of the road and had someone pick up the car. I went to trade the car in and learned the vehicle had been in two accidents and was reported as a total loss. Per the Carfax report. We were never told it was a salvaged vehicle or we would never purchased it for our family vehicle. The vehicle is too unsafe to put back on the road. I bought a 2017 Ford Explorer at a dealership and traded in the 2016 Ford Explorer at a significant loss. The vehicle was in my possession for approx. two months where it spent most of the time in different Ford repaid shops INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Nov 25, 2023
2016 FOR EXPLORER SPORT - PURCHASED BRAND NEW. VEHICLE HAS 15K MILES NOW AND I AM HEARING A LOUD POPPING / CREAKING SOUND THAT OCCURS WHEN TURNING THE STEERING WHEEL EITHER LEFT OR RIGHT WHEN THE CAR IS IN MOTION. IT'S MOST NOTICEABLE AT A SLOWER RATE OF SPEED WHEN TURNING INTO A PARKING SPACE OR TURNING FROM A COMPLETE STOP. TODAY, ON 3 SEPARATE OCCASIONS, WHEN TURNING LEFT THE STEERING LOCKED UP AND I HAD TO JERK THE STEERING WHEEL TO THE RIGHT IN ORDER TO GET THE VEHICLE TO GO STRAIGHT AGAIN. EACH TIME THIS HAS HAPPENED THERE IS ANOTHER LOUD POP SOUND THAT CAN BE HEARD. THIS IS A MAJOR COMPLAINT ACROSS THE BOARD WITH 2014 - 2016 EXPLORERS ALONG WITH THE WHEEL BEARING, SUSPENSION AND LOSS OF POWER COMPLAINTS.
Feb 26, 2018
WHEN DRIVING ON A HIGHWAY AT APPROXIMATELY 70MPH, I COMPLETELY LOST CONTROL OF MY VEHICLE FOR NO KNOWN REASON. I VEERED ACROSS 3 LANES OF TRAFFIC AND BACK ACROSS 2 MORE. CARS WERE SWERVING AROUND ME AND MIRACULOUSLY I WAS NOT IN AN ACCIDENT. I PULLED OVER TO THE SIDE OF THE ROAD AND OTHER CARS TRAVELING BEHIND ME AT THE TIME DID TOO. WE COULDN'T SEE ANY REASON WHY THE CAR WASN'T WORKING PROPERLY SO AFTER CATCHING MY BREATH, I TRIED TO GET BACK ON THE ROAD. I COULD FEEL MY CAR INTERMITTENTLY "SLIPPING". IT FELT AS THOUGH IT WAS LOSING TRACTION AND I WAS LOSING CONTROL AND NOT ABLE TO STEER. I ULTIMATELY PULLED OVER AND CALLED A TOWTRUCK AS I KNEW MY VEHICLE WAS UNSAFE TO DRIVE. THE TOW TRUCK DRIVER SAW THAT MY REAR TIRES WERE COMPLETELY BALD ONLY ON THE INSIDE. MY CAR HAD 27,000MILES ON IT AT THE TIME. I REPLACED THE BACK 2 TIRES THAT DAY. AND THE FRONT 2 THE FOLLOWING DAY. 2 WEEKS LATER, MY CAR WAS NOT DRIVING PROPERLY AND I BROUGHT IT INTO A LOCAL FORD DEALERSHIP FOR SERVICE. THEY PERFORMED A DIAGNOSTIC. THEY TOLD ME MY REAR SUSPENSION WAS A MESS, THE UPPERCONTROL ARM NEEDED TO BE REPLACED, THE BUSHINGS ON MY BACK RIGHT WHEEL WERE LOSE AND HAD A LOT OF PLAY AND THAT NONE OF THIS WAS COVERED UNDER MY B2B WARRANTY BECAUSE THE RIGHT REAR TOW LINK WAS BENT AND THE WEDDINGS WERE LOSE. ALSO, THE TIRES I PUT ON 2 WEEKS AGO WERE STRIPPED BALD ON THE INSIDES AGAIN AND NEEDED TOMBS REPLACED. MY CAR HAS NEVER BEEN IN AN ACCIDENT. FORD RECALLED 75,000 EXPLORES MADE IN 2014-15 DUE TO FAULTY REAR SUSPENSION FROM IMPROPER WELDING OF TOW LINKS. I BELIEVE MY CAR IS A DEMONSTRATION THAT THIS IS STILL AN ONGOING MANUFACTURER ISSUE WITH THESE VEHICLES AND I WANT TO PROPERLY REPORT IT SO THAT OTHER YOUNG MOTHERS DO NOT HAVE THE SAME DANGEROUS ENCOUNTER THAT I HAD.
Mar 09, 2017
UNKNOWN OR OTHER,VISIBILITY
3 complaints
I was driving my 2016 Ford Explorer on I-65 October 19, 2023, in the afternoon. I thought something flew off of one of the two semis in front of me and hit my windshield on two separate times, within a few seconds of each other. When I arrived home, I checked to see if I had any damages, and I was surprised to see pieces missing from the passenger side of my windshield. This morning, October 20, 2023, I went to a local Ford Dealership and was informed there is no recall regarding the upper and lower pillars (windshield trim pieces). I called Ford Headquarters and was told they hadn't heard of this issue before, and I filed a claim. I researched and found two articles: January 31, 2023, USA Today and Carscoops, February 03, 2023, regarding NHTSA investigating these same pieces flying off of Ford Explorers, and I found pictures on the internet that look exactly like my vehicle when these pieces flew off.
Oct 20, 2023
The plastic piece on the drivers' side of the windshield was loose and flapping. Before I could get it looked at and fixed, while driving down the highway one morning I heard a noise and in my rearview mirror saw black plastic shattering all over the road. If I didn't realize quickly what the noise was, I could have reacted and caused myself harm in an accident and if there were cars close to me, or a motorcycle or even worse a pedestrian, they could have been damaged or hurt. The missing piece has not been replaced or inspected so it is still missing. I had noticed the flapping plastic piece a couple weeks prior to the incident, a month tops.
Feb 02, 2023
The trim on the passenger side pillar next to the windshield detached and flew off of the vehicle while driving on the highway. The trim piece was not recovered as it is unknown where it landed. There was traffic on the highway behind the vehicle and it could have hit another vehicle or later been run over by another vehicle if it landed on the road. The vehicle was subsequently taken to a Ford dealership to have the missing part replaced.
Feb 01, 2023
STEERING,LANE DEPARTURE
3 complaints
To whom it may concern the rack and pinion in my 2016 Ford Explorer fail 3 times one before I bought my truck from the dealer the person who trade it in was because of the rack and pinion. the rack and pinion on my truck that I purchased from the dealer. gave out two three years later. after I purchased my truck, I replace. the rack and pinion it cost me 1300 dollars. and now it fails again. I don't have another 1300 dollars to purchase. another rack and pinion I believe that it's an electoral problem from the manufacture. of the Ford explorer.
Feb 16, 2023
"Steering Assist Fault" and Lane Keeping Sys. Malfunction" faults appeared on my dash display. The vehicle is available for inspection if requested. When the faults lit up, I was unable to steer the vehicle. It was as if the steering was completely locked up. Fortunately I was driving down the driveway at the time and was able to stop before entering the roadway. If this would have faulted while on the road at any speed I'm sure an accident or death would have resulted from not being able to steer the vehicle. I took it in to a repair shop where they said to fix it would require the rack to be replaced and programmed. They recommended taking it to a dealership to be repaired. This appears to be a known problem to the vehicle manufacture but no recalls have been put out. Parts alone I was quoted $2,500 not including labor and programming costs. Vehicle has only been inspected by a repair shop. Symptoms prior to failure - I bought the car used from a dealership. Took the car back to the dealership a few weeks after purchase because I kept hearing a grinding sound coming from the front end while traveling at highway speed. They test drove it and inspected and said they could not find anything wrong. They ended rotating the tires. This did not help. Drove the car for a year feeling like something was wrong under the hood. Summer of 2022 the air vent control actuator went out and the car would not switch off from defrost mode. I had that replaced by a repair shop. December 22, 2022 as I pulled into the driveway I heard a popping sound coming from the front end as i turned into the driveway. The next morning, Dec 23, 2022 while heading down my driveway the faults appeared and I was unable to steer.
Jan 12, 2023
Steering wheel locked up going 40mph.Received warning for steering fault and for lane keeping system. Restarting vehicle did not help.
Jun 26, 2022
ELECTRONIC STABILITY CONTROL (ESC)
3 complaints
WHILE DRIVING THE TRACTION CONTROL AND ABS LIGHTS COME ON. SYSTEM HAS STABILITY CONTROL WARNING. WHILE DRIVING THIS CAUSES BRAKES TO LOCK UP. MY WIFE ALMOST CRASHED DUE TO THE BRAKES LOCKING. ONCE YOU TURN OFF THE CAR IT WILL RESET AND EVERYTHING APPEARS NORMAL UNTIL IT HAPPENS AGAIN. UNFORTUNATELY THIS INCIDENT DOES NOT STORE ANY CODES IN THE SYSTEM. WE HAVE HAD THE 2016 EXPOLORER IN THE SHOP MULTIPLE TIMES AND THE DEALERSHIPS HAVE DONE NOTHING TO FIX THE ISSUE. BECAUSE THERE ARE NO CODES THEY ARE DOING NOTHING. THEY DO NOT RESEARCH THE ISSUE NOR HAVE THEY TRIED TO FIX ANYTHING. THERE ARE MULTIPLE COMPLAINTS ABOUT THIS AND A PROCEDURE NEEDS TO BE ESTABLISHED TO DIAGNOSE AND FIX THE PROBLEM. THIS IS A SERIOUS SAFETY ISSUE AND NEEDS TO BE ADDRESSED BY FORD BEFORE SOMEONE DIES. MY WIFE WILL NO LONGER DRIVE THIS VEHICLE BECAUSE SHE FEEL UNSAFE.
Oct 03, 2020
LOSS OF STEERING WHILE TRAVELING 70MPH, ON EXPRESSWAY,EXACTLY LIKE RECALL ON PREVIOUS YEARS. HAD DEALER FIX JAN 2016 ONLY TO GO OUT AGAIN IN JAN 6,2017, WITH 37000 MILES. DEALER REPAIRED WITH UPDATED PART. NEEDS TO BE INCLUDED WITH RECALL. RECALL 14S06 (14V286000 STEERING: ELECTRIC POWER ASSIST SYSTEM),
Feb 14, 2018
I WAS DRIVING ON THE HIGHWAY AND THE CAR LOST POWER WRENCH LIGHT APPEARED ON MY DASH I WENT FROM 65 T0 10 MILES PER HOUR, WHEN I TOOK IT TO MY DEALER THE WRENCH LIGHT DISAPPEARED,AND THEY SAID THEY COULDN'T PUT IT ON THE MACHINE IF THERE WASN'T A LIGHT ON THE DASH, I EXPLAINED THE PROBLE THEY SAID IT WAS THE ELECTRONIC THROTTLE BODY AND THEY ARE ON BACK ORDER, DON'T KNOW WHEN YOU WILL GET ONE.
Jun 13, 2016
STRUCTURE,ENGINE
2 complaints
The contact owns a 2016 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 21V316000 (STRUCTURE), 24V031000 (STRUCTURE), and 25V347000 (STRUCTURE). However, the parts to do the recall repairs were not yet available. The contact stated that while the vehicle was parked, the contact became aware that rainwater was leaking inside the vehicle and standing water had accumulated on the carpet. The water was leaking from the front door, the roof near the dome light, and the glove compartment. The contact was unsure of where the water was entering the vehicle. The contact stated that there was a musty odor inside the vehicle. Most recently, while driving at an undisclosed speed, there was an abnormal burnt odor inside the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer; however, the vehicle was not diagnosed or repaired. The contact stated that the check engine warning light was constantly illuminated since the vehicle was purchased. The manufacturer was not made aware of the failure. The failure mileage was unknown.
Oct 14, 2025
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING, THE CONTACT NOTICED AN ABNORMAL ODOR INSIDE THE VEHICLE RESEMBLING CARBON MONOXIDE WHILE THE RECIRCULATION AIR CONDITIONER WAS ACTIVATED. THE PASSENGER (THE CONTACT'S WIFE) NOTICED THE ODOR. THE CONTACT SAW THE FAILURE ON THE NEWS AND CALLED THE DEALER (L&S TOYOTA, 248 AUTO PLAZA DR, BECKLEY, WV, 25801; 304-252-8548; EXT 231) WHERE THE DEALER ADVISED THE CONTACT THAT THEY WERE TRYING TO SCHEDULE AN APPOINTMENT. THE CONTACT FAXED OVER SIX PAGES OF INFORMATION FOR THE DEALER TO TRY AND REMEDY THE CARBON MONOXIDE FAILURE. THE VEHICLE YEAR AND MODEL WAS INCLUDED IN INVESTIGATION NHTSA NUMBER: EA17002 (STRUCTURE, ENGINE). THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 20,000.
Aug 04, 2017
SUSPENSION,STRUCTURE
2 complaints
Both an and b pillars are junk and dealer inspected a pillars and said they were fine? And there’s no remedy for the b ones which is annoying. My car shakes bc of a transmission shutter at 100k miles it’s not bad but why is jt going on? And wind noise because of the pillars I’m hoping? Needing help from someone.
Sep 23, 2025
THE RECALLED TOE LINK ON THE REAR SUSPENSION BROKE 3 MONTHS AFTER IT WAS REPLACED AND CAUSE A CRASH WHILE DIVING DOWN THE HIGHWAY, SLOWING FOR A SPEED ZONE FOR A TOWN. INVOLVING BODY DAMAGE. AND THE VEHICLE WAS REPAIRED AND 1 WEEK AFTER GETTING IT BACK FROM THE DEALER THE LINK BROKE FOR A SECOND TIME, WHILE ON A CURVE WITH CRUISE CONTROL ON ROAD CONDITIONS WERE DRY BOTH TIMES.WE HAVE OWNED THE VEHICLE FOR 6 WEEKS TOTAL AND HAVE ONLY BEEN ABLE TO DRIVE FOR 2 OF THEM.
Mar 03, 2020
ELECTRICAL SYSTEM,VISIBILITY
2 complaints
The contact owns a 2016 Ford Explorer. The contact stated that while driving in the rain, water leaked inside the vehicle from the dome light. No warning lights were illuminated. The contact stated that the moonroof failed to function as intended and was no longer able to be opened. The contact stated that there was mold on the front driver's side and front passenger's side seats, as well as inside the cupholders. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired. However, the contact was informed that the moonroof assembly needed to be repaired. The contact had a friend inspect the vehicle and found a burnt wire underneath the steering wheel unit. The manufacturer was notified of the failure. The failure mileage was approximately 153,000.
Sep 05, 2025
The contact owns a 2016 Ford Explorer. The contact stated that while driving 30 MPH, the A/C unit became inoperable. The vehicle was driven to a dealer and an independent mechanic to be diagnosed. The contact was informed that there was a leak in the A/C unit. The contact was informed that the A/C unit needed to be replaced. The vehicle was repaired but the failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 19,000.
Oct 02, 2024
EXTERIOR LIGHTING
2 complaints
Issues with headlight housing unit getting moisture in it causing lights to malfunction. Driver headlight won't work and passenger headlight will turn off while driving then back on and off again. It does this continously at random making it dangerous for myself and other drivers at night. I've spoke with Ford explaining there is a recall for some 2016 models but not one under my VIN so they won't fix it since it's not. I'm hoping the recall can be extended to cover my VIN.
Apr 26, 2025
FORD DESIGNED THE HEADLIGHTS IN THE 2016 FORD EXPLORER SO THAT THE LED LOW BEAM IS BUILT INTO THE HOUSING. SO YOU EITHER HAVE TO REPLACE THE VERY EXPENSIVE HOUSING (1,000) WHEN YOUR LOW BEAM GOES OUT OR DRIVE WITH LESS VISIBILITY. MOST PEOPLE DO NOT HAVE $1,000 JUST LAYING AROUND.
Feb 11, 2021
ENGINE AND ENGINE COOLING,STRUCTURE
2 complaints
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The contact stated that while the vehicle was at a car wash, the driver's side A-pillar trim detached from the vehicle. The local dealer was contacted and replaced the A-pillar trim. The contact stated that after leaving the dealer after the repair, the driver's side A-pillar became loosened. The A-pillar trim was replaced. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that on a separate occasion, while the vehicle was parked, the contact noticed coolant leaking from the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer and was diagnosed with coolant intrusion into the head gasket. The contact was informed that the water pump and timing chain needed to be replaced. The vehicle was not repaired for the most recent failure due to the cost. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 120,000. VIN tool confirms parts not available.
Mar 21, 2025
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING AT ANY SPEED, THE CONTACT SMELLED EXHAUST FUMES WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE SHARPE MOTOR DEALER WHERE IT WAS DIAGNOSED THAT THE BUMPER NEEDED TO BE REPLACED. THE FUME ODOR REMAINED. THE VEHICLE WAS TAKEN BACK TO THE DEALER, BUT THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE SOURCE OF THE FUMES. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE WAS NOT REMEDIED. THE FAILURE MILEAGE WAS 16,000.
May 24, 2017
POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM
2 complaints
The power transfer unit is broken. Symptoms are vehicle shuddering, vehicle sounds like it is going to stall. This could cause a major accident at any moment.
Jun 06, 2024
In August 2023, my vehicle began to make a popping noise and began to lose power when attempting to accelerate. It was diagnosed by the repair shop as a turbo going bad. I repaired the turbo. In December 2023, the check engine light came on. The repair shop indicated that the lifters and cam shafts were bad and caused scoring to the engine block, requiring the engine to be replaced. The repair shop asked if I had been changing the oil regularly. I indicated that I did change the oil per when the vehicle would notify me it was time. The repair shop noted that I changed the oil every 10k miles. Per the repair shop, not changing the oil regularly (because the Ford vehicle system designed to tell me when to change the oil) ultimately caused me to need to replace the turbo and the engine. All because the oil was not changed more frequently 3-5k miles per the repair shop. I've spent $15k in repair costs since August 2023 because I was relying on the Ford vehicle's notifications as to when it needed oil. The vehicle is not even worth this much blue book. For a 8.5 year old vehicle that has been well cared for, I do not think these parts should have failed and I think Ford should have set the timing for oil change notifications more frequently if this is what is needed by the engine to keep it in good repair. It literally indicates the % of time before the oil needs to be changed.
Mar 22, 2024
STEERING,TRACTION CONTROL SYSTEM
2 complaints
The contact owns a 2016 Ford Explorer. The contact stated while driving approximately 45 MPH, the steering wheel became very firm. The contact stated that the "Steering Assist Failure" message was displayed, and the Traction Control Warning light was illuminated. The vehicle was taken to the residence. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 108,000.
Mar 15, 2024
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING 65 MPH, THE TRACTION CONTROL INDICATOR ILLUMINATED AND THE STEERING SEIZED. THE CONTACT PULLED THE VEHICLE OVER AND ATTEMPTED TO TURN OFF AND RESTART THE VEHICLE, BUT THE STEERING WAS LOCKED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DISCOVERED THAT THE ENTIRE FRONT RACK AND PINION SYSTEM NEEDED TO BE REPLACED. THE TOTAL COST, INCLUDING TOWING, WAS $2,300. FORD OF HIBBING (2627 E BELTLINE, HIBBING, MN 55746, (218) 262-3881) STATED THERE WERE NO RECALLS AND THE WARRANTY RECENTLY EXPIRED; THEREFORE, THEY WOULD NOT ASSIST WITH THE REPAIR COST. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 31,060.
Aug 23, 2019
UNKNOWN OR OTHER,STRUCTURE
2 complaints
I was driving on the highway and heard a loud noise didn’t know what it was until I got home and realized my windshield trim on passenger side was not on there anymore. It had flown off while driving down the highway.
Nov 15, 2023
Windshield trim pieces flying off while driving down the highway.
Feb 16, 2023
AIR BAGS,SEATS
2 complaints
The airbag fault light on the dash of my 2016 Ford Explorer recently illuminated. I took it to Christian Brothers Automotive, who did a complete diagnostics check. They determined that the inflatable seat belt should read 2.2 Ohms but it reading at 5.5 Ohms, which is causing the light to illuminate. They stated that the inflatable seat belt needs to be replaced. This appears to be the same issue with a Ford recall notice issued on January 21, 2022 under Customer Satisfaction Program 21B11 related to 2014, 2015, and 2016 Ford Explorers. However, my VIN does not appear on the list of effected vehicles and Ford is refusing to repair it under the recall until it is added to the list.
Aug 04, 2023
MY DRIVER SIDE AIRBAG LIGHT IS ON MY DASH I HAVE PLUGGED IN AND UNPLUGGED ALL OF THE SEATBELTS RESET THE AIRBAG LIGHT AND IT STAYS OFF FOR A WHILE. THIS IS DEFINITELY A SAFETY ISSUE I UNDERSTAND IT IS EITHER A SENSOR OR THEY ARE HAVING PROBLEMS WITH THE WIRING HARNESS THIS SHOULD BE ADDRESSED IN A RECALL. THE FRONT PASSENGER SIDE SEAT WARMER/COOLER DOES NOT WORK, NOT SURE IF THAT ISSUE IS PART OF THE AIRBAG LIGHT PROBLEM.
Jan 28, 2021
ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE
2 complaints
The contact owns a 2016 Ford Explorer. The contact stated that while driving approximately 65-70 mph, there was an abnormal exhaust odor entering the vehicle. When the accelerator pedal was released, the odor dissipated. There were no warning indicator lights illuminated. The driver and passenger sustained a headache due to the odor but medical attention was not provided. The vehicle was taken to an independent mechanic who stated that the seal was broken. Additionally, the mechanic informed her to use premium or Chevron fuel. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, who opened a case, and referred her to the NHTSA hotline. The failure mileage was approximately 112,000.
May 08, 2023
SINCE EARLY OCTOBER 2016, I'VE HAD A NEAR-CONSTANT EXHAUST SMELL, SIMILAR TO WHAT NATURAL GAS OR SULFUR SMELLS LIKE, IN THE CABIN OF MY VEHICLE THAT IS RESULTING IN HEADACHES (LITERALLY) FOR MY ENTIRE FAMILY. DEALERSHIP HAS MADE MULTIPLE ATTEMPTS TO REPAIR AND HAS BEEN UNSUCCESSFUL. THE EXHAUST FUMES ARE COMING INTO THE CABIN WHEN THE ENGINE IS STARTED AND VEHICLE IS PARKED OR MOVING. IN MY ONLINE RESEARCH, I'VE FOUND THAT FORD IS UNDER INVESTIGATION BY NHTSA FOR THIS ISSUE FOR 2010-15 MODELS, BUT I BELIEVE MY 2016 MODEL IS AFFECTED AS WELL. *TR
Jan 08, 2017
ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM
2 complaints
Everytime my ac/heat is on it affects my engine as I’m driving. My speedometer fast jumps. As soon as I turn it off it seems to run better. I made a complaint a week ago about something going on with my fuel and fan running high speed. I have a foul smell in my car. I thought for awhile it was something outside but now I believe it’s coming from my car. It smells like fuel/rubber/sewer if that makes sense.
Apr 21, 2023
My fuel evap pump check engine light keeps coming on. I’ve owned this vehicle since July 2022 and I have paid for the evap pump 3x’s. My fan constantly runs in the engine. My engine has a stutter when I press the gas. Ford absolutely dropped the ball with this vehicle. I have already paid thousands of dollars (water pump, evap pumps and more) please help on getting this car serviced. I still owe like 20k on this car. I cannot afford to keep getting it fixed. I have 121k miles on it.
Apr 13, 2023
AIR BAGS,UNKNOWN OR OTHER
2 complaints
The water pump goes out and blows the engine. Leave your stranded. They put this engine and makes it to the point you can't fix and cost over 5,000 to fix sounds like lots of issues why the hell has this not been recalled. Very disappointed that people are having this issue and really no recalls on this. Not ok!!!
Mar 04, 2023
I HAVE A FUME SMELLING LIKE BOILED EGGS REALLY STRONG COMING INSIDE MY VEHICLE CAUSING ME TO BECOME NAUSEA WITH HEADACHE AND DIZZINESS
Sep 05, 2017
ELECTRICAL SYSTEM,VISIBILITY/WIPER
2 complaints
The accelerator for the climate controls is malfunctioning. Cannot defrost the windows to see, when driving the windows get so fogged I have to pull over to get them to defrost. Over 50k people online have stated the same issue. The climate controls stop working and there are no recalls from Ford. When I spoke to Ford, the lady made a statement that she’s had many calls with the same issue and it’s definitely a Saftey hazard.
Nov 10, 2022
THERE IS A DESIGN DEFECT IN THE FRONT PARKING SENSORS WHERE AFTER FREEZING, WATER CAN ENTER THE OPENING OF PARKING SENSOR AND SHORT CIRCUIT THE WIRING HARNESS CAUSING THE PARKING AID SYSTEM TO FAULT. THIS PREVENTS THE DRIVER FROM UTILIZING THIS KEY SAFETY FEATURE WHEN PARKING OR BEING ALERTED ON THEIR CLOSE PROXIMITY OF SURROUNDING OBJECTS.
May 12, 2018
FUEL SYSTEM, GASOLINE
2 complaints
Water pump failure which causes the car to stall immediately when it overheats. This appears to be a common issue with 2016 Ford Explorers
Sep 28, 2022
The contact owns a 2016 Ford Explorer. The contact stated that the vehicle constantly smelled of gasoline. The contact stated that the odor occurred when the vehicle was in motion but was stronger when the vehicle was idle. The vehicle was taken to an independent mechanic who was not able to properly diagnose the vehicle. The mechanic sealed several locations where the odor might have been coming from. The vehicle was taken to the dealer because the gasoline odor was stronger on the outside of the vehicle. The dealer was not able to determine the cause of the failure and referred the contact to NHTSA for assistance. The contact stated that the failure had gotten progressively worse. The manufacturer was not notified of the failure. The failure mileage was 90,000
Dec 10, 2021
AIR BAGS,ENGINE
2 complaints
Air bag dashboard light turned in January 2022 until now part is back order. Secondly over heating problems at 60 mph on July 16, 2022 I was told it was the cooling fans and was fixed and didn’t fixed the problem now I was told is the active grilled shutters malfunctioning
Sep 07, 2022
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING 60 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED; HOWEVER, THE VEHICLE FAILED TO RESPOND. THE CONTACT ALSO STATED THAT THE CHECK ENGINE WARNING LIGHT AND THE AIR BAG WARNING LIGHT WERE ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER TO BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 9,000. THE VIN WAS NOT AVAILABLE.
Jul 19, 2016
POWER TRAIN,FUEL/PROPULSION SYSTEM
2 complaints
ON MULTIPLE OCCASIONS TRANSMISSION WAS SLIPPING WHICH LED TO AN EVENTUAL COMPLETE FAILURE. EXPLORER WAS ON CA HIGHWAY 76 GOING WESTBOUND WHEN TRANSMISSION FAILED. DRIVER WA FORCED TO DODGE TRAFFIC AND COAST TO AN EMERGENCY STOP AT THE RIGHT SIDE OF THE HIGHWAY. EXPLORER HAD TO BE TOWED.
Apr 12, 2021
BRAND NEW 2016 FORD EXPLORER WITH ONLY 6779 MILES. UNABLE TO ACCELERATE FROM A STOP THROUGH A BUSY INTERSECTION. NO INDICATION THAT ANYTHING WAS WRONG PRIOR TO THIS. SEVERAL DASH LIGHTS CAME ON. CAR WENT INTO LIMP MODE NOT ALLOWING ME TO ACCELERATE ABOVE 15 MPH. CHECK ENGINE LIGHT, POWER TRAIN LIGHT AND AIRBAG LIGHT ALL ILLUMINATED. HAD CAR TOWED TO DEALERSHIP. THROTTLE BODY FAILURE INDICATED AS THE ISSUE. PART WAS BACK ORDERED FOR TWO WEEKS. VERIFIED ONLINE THAT MANY OTHER NEW EXPLORER OWNERS HAVE HAD THIS SAME ISSUE AROUND THE SAME MILEAGE. FORTUNATELY I WAS NOT ON A BUSY HIGHWAY LIKE SOME.
Jul 15, 2016
SERVICE BRAKES,ENGINE
2 complaints
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT WHILE HAVING A ROUTINE OIL CHANGE AT WALDORF FORD (2440 CRAIN HWY, WALDORF, MD 20601, (888) 709-3528) THE TECHNICIAN INFORMED THE CONTACT THAT THE ENGINE BLOCK WAS LEAKING AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. A FEW DAYS LATER A BYSTANDER INFORMED THE CONTACT THAT THERE WAS WATER IN THE PASSENGER'S SIDE REAR BRAKE LAMP AND THAT THE BRAKE LAMP FAILED TO ILLUMINATE WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT MENTIONED NHTSA CAMPAIGN NUMBER: 15V605000 (FUEL SYSTEM, GASOLINE) AS A POSSIBLE SOLUTION TO THE FAILURE HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA TO FILE A COMPLAINT. THE FAILURE MILEAGE WAS APPROXIMATELY 85,000.
Mar 29, 2021
THE VACUUM TUBE ASSEMBLY/ HOSES CORRODED TO THE POINT THE BRAKING SYSTEM WAS COMPROMISED. THE DEALERSHIP'S ASSESSMENT STATES THAT BATTERY ACID SPILLED ONTO THE HOSE AND THE ACID ATE THOUGH IT. WHEN I VISUALLY INSPECTED THE HOSE, THE ONLY PART OF THE HOSE THAT WAS CORRODED WHERE BOTH ENDS WHERE IT CONNECTS TO THE MANIFOLD AND OTHER END. I FIND IT VERY ODD THAT BATTER ACID WILL ONLY SPILL ON 2 OPPOSITE ENDS OF A HOSE, WHICH HAPPENS TO BE WHERE THE CONNECTIONS ARE. THE BATTERY WAS REPLACED AFTER THE ORIGINAL BATTERY'S CORE EXPLODED.
Dec 13, 2018
STEERING,POWER TRAIN,UNKNOWN OR OTHER
2 complaints
I TOOK MY 2016 FORD EXPLORER XLT ON DEC 29TH 2020 TO GET A OIL CHANGE ETC. THEY HAD THE VEHICLE ALL DAY EVEN THOUGH I TOOK IT IN AT 7AM. I PICK IT UP A 4:45 PM THEN DRIVE IT HOME BECAUSE I WORK FROM HOME I DID NOT DRIVE IT AGAIN UNTIL SATURDAY JAN 9TH 2021, WHILE DRIVING IT THAT MORNING I REALIZED THAT THE STEERING WHEEL WAS HARD TO STEER AND THE TRUCK WOULD MAKE NOISES WHEN I TURN THE STEERING IN EITHER DIRECTION. I TOOK IT IN TO THE DEALERSHIP THAT MORNING AND ASKED THE SERVICE CONSULTANT TO TAKE A LOOK AT IT. HE TOLD ME WHILE MY FATHER WAS ON THE PHONE THAT HE BELIEVES IT THE RACK AND PINION AND HE CAN'T TAKE IT BECAUSE THEY ARE BUSY AND IT'S OKAY FOR ME TO DRIVE IT. I ALSO TOLD HIM AT THAT TIME I AM SUPPOSED TO DRIVE OUT OF TOWN AND I WON'T BE BACK FOR AWHILE SO IF THERE IS A PROBLEM I RATHER LEAVE IT SO IT CAN BE FIXED. I HAVE DAMAGED ON MY C5 VERTEBRAE SO I CAN FEEL THE HARDNESS IN THE STEERING. HE ASSURED OR DISMISSED ME BUT HE SAID IT'S FINE. A FEW HOURS LATER THE STEERING WHEEL SEIZED UP AND THE DASHBOARD STARTED MAKING NOISE AND THE WARNING LIGHTS AND MESSAGES STARTED TO DISPLAYING. IT ALMOST KILLED BOTH MY MOTHER AND I ON THE HIGHWAY. IF YOU KNOW NYC HIGHWAY YOU KNOW THERE IS NO SHOULDERS. WHEN I PULLED OF THE ROAD THE STEERING WHEEL LOCKED UP AND I COULD NOT MOVE IT. I HAD TO PAY FOR THE TRUCK TO BE TOWED AND A UBER FOR MYSELF BACK TO THE DEALERSHIP AND THEN PAID FOR ME TO GET HOME. NOW THEY ARE TELLING ME THAT I HAVE TO PAY $2719.81 FOR THE RACK AND PINION REPAIR AND THE ALSO PAY FOR THE STRUT BEARING TO BE REPAIRED WHICH THEY HAVEN'T GIVEN ME THE PRICE FOR IT BECAUSE "IT WAS TOO MUCH TO GIVE ME BOTH PRICE AT ONCE." OH BY THE WAY, THIS IS THE SAME SERVICE CONSULTANT THAT TOLD ME IT WAS FINE FOR ME TO DRIVE AND ALMOST KILLED 2 GENERATION OF MY FAMILY AT THE SAME TIME. I AM PISSED!! NOW I SEE OTHER CUSTOMERS COMPLAINING ABOUT THE SAME ISSUE ON THERE SUV!!
Jan 12, 2021
VEHICLE STEERING BECAME STIFF WHILE DRIVING IN A PARKING LOT, WITH MULTIPLE ERRORS. CANNOT DRIVE VEHICLE SAFELY. HAPPENED WITHOUT WARNING. -HILL START ASSIST NOT AVAILABLE -SERVICE ADVANCETRAC -TERRAIN MANAGEMENT SYSTEM FAULT
Feb 17, 2019
STEERING,ELECTRICAL SYSTEM,ELECTRONIC STABILITY CONTROL (ESC)
2 complaints
SATURDAY JUNE 20TH 2020 THE HILL ASSIST MESSAGE CAME ON AS DID THE ABS AND TRACTION CONTROL LIGHTS CAME ON. THERE IS NO POWER STEERING AND BOTH AXLES ARE MAKING A CLICKING NOISE. I HAVE LEARNED THAT THIS IS THE RACK AND PINION ELECTRONIC POWER ASSIST SYSTEM. EPAS UNIT HAS FAILED. LUCKILY IT WAS IN MY CUL DE SAC TURNING AROUND AND NOT ON THE FREEWAY. MY WIFE PREDOMINANTLY DRIVES THIS VEHICLE. THE STEERING IS VERY DIFFICULT TO MOVE. THE VEHICLE ONLY HAS 64,000 MILES ON IT. IS THIS A PRIVATE RECALL? I HAVE SPOKEN WITH A COUPLE OF OTHER EXPLORER OWNERS THAT FORD "TOOK CARE OF IT" FOR THEM. I HAVE ORDERED THE PART, BUT IT WILL NOT BE THERE FOR A WEEK. THIS CAR IS WELL TAKEN CARE OF AND IS NORMALLY DRIVEN ON CITY STREETS AND OCCASIONALLY ON THE HIGHWAY. *TR
Jun 22, 2020
LOSS OFF POWER STEERING AND STABILITY CONTROL
Apr 25, 2019
ELECTRONIC STABILITY CONTROL (ESC),FUEL/PROPULSION SYSTEM
2 complaints
I STOPPED AT TRAFFIC LIGHT, I HEARD A STRANGE SOUND, AND THE AIRBAG LIGHT CAME ON. I PRESS THE GAS GAS TO CROSS INTERSECTION AND CAR WOULD ONLY GO 3 MILES AN HOUR, I MANAGED TO TURN INTO SIDE STREET, AND TURNED CAR OFF. WHEN I RESTARTED CAR AND I WAS ABLE TO ACCELERATE AND PROCEEDED TO DRIVE TO MY DESTINATION, WHEN I STOPPED AT ANOTHER RED LIGHT IT HAPPENED AGAIN AND THEN ENGINE LIGHT CAME ON. I THEN TURNED OFF CAR AND RESTATED TO FIND ALL WARNING LIGHTS OFF. I THEN DROVE TO AUTO NATION FORD DEALERSHIP. THEY DIAGNOSED WITH A THROTTLE PROBLEM. WHEN CHECKING THE INTERNET I SEE A LOT OF PEOPLE HAVE HAD THIS SAME PROBLEM, IT COULD HAVE BEE A VERY DANGEROUS SITUATION SINCE THIS HAPPENED ST AN INTERSECTION.
Jun 28, 2019
THE VEHICLE WENT INTO LIMP MODE RPM AND SPEED WHERE REDUCED TO 1000 RPM (MAX) AND 5-10 MPH WHILE RESPONDING TO A POLICE MATTER AS THE VEHICLE IS THE POLICE MODEL AND PURCHASED AS A POLICE CAR. UPON RESEARCH, THE ELECTRIC THROTTLE BODY HAS BEEN A PROBLEM FOR A NUMBER OF YEARS AND HAS NOT BEEN ADDRESSED. THIS IS A POLICE VEHICLE AND NOT RELIABLE AT ALL. THE VEHICLE HAS 3960 MILES ON IT AND DEPT IS BEING TOLD IT WILL BE 2-3 MONTHS BEFORE BACK IN SERVICE. RESEARCH DONE ON INTER NET FINDS THIS HAS BEEN AN ON GOING ISSUE WITH FORD FOR A NUMBER OF YEARS AND BEING OVER LOOKED BY THE REGULATING AGENCIES.
Jun 07, 2016
TIRES,WHEELS
2 complaints
THE SIDE WALL OF MY HANKOOK 255/50 R /20 VENTUS S1 NOBLE 2 TIRE BLEW OUT. I HAVE A 2" HOLE IN THE SIDE WALL OF THE TIRE. I WAS AT A STOP SIGN ON A CITY STREET, AND JUST STARTED MOVING WHEN THE SIDE WALL BLEW OUT. IT SOUNDED LIKE A LARGE BALLOON EXPLOSION AND THE TIRE WENT FLAT INSTANTLY. SOME HANKOOK TIRES HAVE BEEN RECALLED BUT THE LOCAL FORD DEALER TOLD ME NOT THIS ONE. THESE HANKOOK TIRES SHOULD BE RECALLED.
Nov 29, 2018
ALL 4 HANOOK TIRES DOT # 5MNC 1A H (0216) 255/50/R20 TREADS HAVE BEEN CHIPPING RESULTING IN UNSAFE CONDITIONS AND EXCESSIVE WEAR. TIRES COMPLETELY WORN OUT AT 23,000 MILES. MANUFACTURER IS AWARE IF THIS RESULTING FROM NEW COMPOUNDS (MATERIALS) USED IN MANUFACTURING. HIGH SPEED BLOWOUTS HAVE BEEN REPORTED FOR THIS PARTICULAR TIRE YET NO RECALL HAS BEEN ISSUED FOR THIS TIRE DESPITE ITS DEFECTS AND SAFETY CONCERNS. I FIRST NOTICE IT ON TWO FRONT TIRES JUST PRIOR VEHICLE WAS TAKEN IN FOR ANNUAL SERVICE MAY 2017.
Aug 16, 2018
ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE
2 complaints
I HAVE A 2016 FORD EXPLORER LIMITED EDITION UNDER MY DADS NAME AND MY WIFE IS THE PRIMARY DRIVER ON IT. AFTER GETTING OUR CAR I DROVE IT DAILY AS COMMUTER FOR 2 MONTHS AND SOMETIMES I SMELL SOMETHING BAD INSIDE LIKE BURNED TIRES BUT I JUST IGNORED IT BECAUSE I SAID MY CAR IS BNEW AND MAYBE ITS FROM OUTSIDE AND AFTER THAT MY WIFE START DRIVING IT BUT LAST DECEMBER 2016 WE WENT TO VEGAS AND I JANSSEN (HUSBAND) IS THE ONE DRIVING ON THE CAR AND SMELLED SOMETHING BURNED TIRES INSIDE THE CAR WHILE CRUISING ON IT, I CHECKED THE TIRES/BREAK OUTSIDE BUT I DONT SMELL IT FROM OUTSIDE, SO AFTER THAT WE WENT TO OUR DEALER AND CHECKED IT FOUND OUT THERES A CARBON MONOXIDE PRESENT INSIDE AND THEY FIXED IT BY COVERING THE HOLES OF THE CAR THAT MAY BE THE ENTRY OF SMOKE FROM OUTSIDE AND UPDATING THE SYSTEM AS PER SERVICE GUY TOLD ME "RENE" AND SAID EVERYTHING WORKS WELL NOW. AFTER FEW MONTHS IT WAS JUNE 2017 I SMELLED IT AGAIN AND CONCERNED ME MORE BECAUSE MY WIFE IS PREGNANT AND I KNOW CO2 IS REALLY BAD ON OUR HEALTH AND I KNOW THAT BECAUSE WE ARE BOTH NURSES AND WE SENT IT BACK TO THE DEALER AND MY SERVICE GUY "LUIS " TOLD ME THEY PUT SOME RUBBER IN THE REAR DOOR FOR THE PURPOSE OF SEALING THE DOOR THAT MAYBE THE SMOKE FROM THE EXHAUST IS THE ONE CAUSING IT AND TAKE NOTE " THE CAR STAYS 1 WEEK IN THE SERVICE DEPARTMENT". AND NOW SEPT 2017 THE SAME THING IS HAPPENING AND I CALLED MY DEALERSHIP, I SPOKE TO LUIS AND CASEY AND THEY TOLD ME THERE'S STILL WAITING FOR THE SERVICE MANAGER BECAUSE THEY ARE BUSSY, I TOLD THEM MY CONCERN THAT MY WIFE IS PREGNANT SHE'S ON 8 MONTHS NOW AND IT MAKES ME REALLY CONCERNED OF WHAT IS GOING ON WITH THE CAR BUT THEY JUST TOLD ME TO WAIT, AND MY WIFE DAILY CAR IS IT. SO INCASE SOMETHING HAPPEN WITH MY FAMILY THIS IS NOT REALLY SAFE FOR US, SO I REALLY NEED A BIG HELP FROM YOU NHTSA THAT WE CAN SOLVE THIS PROBLEM, I HEARD OTHERS TOO ESP POLICE. TY
Sep 11, 2017
I JUST GOT BACK MY VEHICLE FROM THE DEALERSHIPS SERVICE CENTER AND ACCORDING TO THEIR FINDING THEIR WAS AN ISSUE WITH THE VEHICLES STARTER. I DROVE HOME PARKED THE CAR IN THE GARAGE THEN TURNED OFF THE IGNITION. THE VEHICLE WOULD TURN OFF, SO I PUSHED THE START BUTTON AGAIN BUT STILL DID NOT TURN OFF THEN SECONDS LATER I SMELL SMOKE. I IMMEDIATELY BACKED UP TO HAVE THE CAR OUTSIDE THE GARAGE . I HIT THE START BUTTON AGAIN TO TURN OFF AND THIS TIME THE ENGINE SHUT DOWN. HEAVY SMOKE WAS COMING OUT OF THE ENGINE COMPARTMENT SO I JUST STOOD AT A DISTANCE . 10-30 MINUTES LATER AS THE SMOKE SUBSIDED I DECIDED TO POP THE HOOD OPEN AND STILL THERE'S SMOKE FROM THE ENGINE COMPARTMENT. I HAVE A VIDEO BUT CANNOT ATTACH.
Jan 05, 2017
ENGINE AND ENGINE COOLING,UNKNOWN OR OTHER
2 complaints
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING 60 MPH, THERE WAS AN ABNORMAL HYDROGEN SULFIDE ODOR. THE VEHICLE WAS TAKEN TO A LOCAL DEALER (HAYFORD FORD LOCATED AT 1330 301ST AVE NW ISANTI, MN 55040 763-689-5555), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND OPENED CASE NUMBER: CAS12775863. NO FURTHER ASSISTANCE WAS PROVIDED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 26,000. ..UPDATED 08/22/17 *BF UPDATED 09/28/2017*JS *CN
Jul 24, 2017
CAR HAS AN AWFUL SMELL WHEN USING THE CLIMATE CONTROL, DEALER SAID THERE WAS AN EXHAUST LEAK INTO THE TURBO, THEY REPLACED THE TURBO AND THE SMELL STILL PERSIST. CAR HAS BEEN AT DEALERSHIP FOR A MONTH NOW. SMELL IS STRONGEST WHEN DRIVING AND CLIMATE CONTROL IS ON. *TR
Dec 19, 2016
ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,ENGINE
2 complaints
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE VEHICLE LOST POWER. IN ADDITION, THE ACCELERATOR PEDAL WAS DEPRESSED BUT THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 8,000. ...UPDATED 12/14/16 *BF
Sep 21, 2016
I RENTED A 2016 FORD EXPLORER FROM AVIS AT THE PORTLAND (ME) AIRPORT (AVIS VEHICLE #40933351). ON FRIDAY, JULY 15TH, THE UNIT STALLED AS I PULLED INTO AN INTERSECTION. THE ACCELERATOR WAS NON-RESPONSIVE AND THE CAR MOVED AT A VERY REDUCED RATE OF SPEED. SEVERAL LIGHTS ON THE DASHBOARD LIT UP - CHECK ENGINE, AIRBAG, AND A NOTE CAME UP TO CHECK THE OWNER'S MANUAL. I WAS ABLE TO FINISH CROSSING THE INTERSECTION AT THE SLOWER SPEED AND PULL TO THE SIDE OF THE ROAD. I SHUT THE CAR OFF AND RESTARTED IT AND IT OPERATED PROPERLY FOR A WHILE. LATER THAT NIGHT, I STOPPED AT A STOP LIGHT. WHEN THE LIGHT TURNED GREEN, I MADE A LEFT HAND TURN. ONCE AGAIN, THE ACCELERATOR STOPPED WORKING AND THE DASHBOARD LIT UP WITH MULTIPLE WARNING LIGHTS. I PULLED TO THE SIDE OF THE ROAD AND CALLED AVIS ROADSIDE ASSISTANCE. THE PERSON ON THE LINE TOLD ME THIS WAS A COMMON ISSUE WITH FORD EXPLORERS AND THAT I HAD TO TURN THE CAR OFF, STEP ON THE ACCELERATOR, THEN PUT MY FOOT ON THE BRAKE AND RESTART THE CAR TO CLEAR THE FAULT BUT THE CHECK ENGINE LIGHT WOULD STAY ON. THE CHECK ENGINE LIGHT STAYED ON BUT I WAS ABLE TO PULL BACK ONTO THE ROAD AT FULL SPEED. APPROXIMATELY 1/4 MILE DOWN THE ROAD I STOPPED AT A TRAFFIC LIGHT. ONCE AGAIN, I BEGAN TO CROSS THE INTERSECTION WHEN THE ACCELERATOR STOPPED WORKING AND THE DASHBOARD LIT UP. I PULLED OVER AND RESET THE CAR AS I HAD DONE BEFORE AND PROCEEDED TO DRIVE AWAY. A FEW HUNDRED FEET AWAY, THE ACCELERATOR STOPPED WORKING AGAIN AND THE DASHBOARD LIT UP. I WAS ABLE TO PULL OVER, RESET THE CAR AND DRIVE AWAY. THIS IS AN EXTREMELY DANGEROUS CONDITION THAT NEEDS TO BE FIXED IMMEDIATELY. THE ACCELERATOR STOPS WORKING WITHOUT WARNING AND THE CAR ONLY TRAVELS AT A VERY SLOW SPEED THAT IS NOT CONTROLLED BY THE ACCELERATOR. 3 OUT OF 4 TIMES IT HAPPENED IN THE MIDDLE OF AN INTERSECTION. IF THERE WAS ONCOMING TRAFFIC, I WOULD HAVE BEEN HIT.
Jul 26, 2016
STEERING,ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM
2 complaints
VEHICLE WAS PROCEEDING AND ALL POWER TO THROTTLE STOPPED. POWER STEERING WENT OUT. VEHICLE COASTED TO STOP IN TRAFFIC TURN LANE. FORD STATED THIS IS A PROBLEM WITH VEHICLES THROTTLE BODY
Aug 10, 2016
WHILE DRIVING ON A BUSY HIGHWAY WITH MY THREE CHILDREN I LOST ALL POWER TO MY VEHICLE JUST BARELY MAKING IT OUT THE WAY OF A SENI TRUCK. THE EXPLORER WAS PURCHASED IN MARCH OF THIS YEAR BRAND NEW TO AVOID PROBLEMS LIKE THIS. DOES SOMEONE HAVE TO BE KILLED BEFORE A RECALL IS ISSUED?!?!?!?!!!
Aug 10, 2016
VEHICLE SPEED CONTROL,FUEL/PROPULSION SYSTEM
2 complaints
I WAS DRIVING IN THE LEFT LANE OF AN INTERSTATE HIGHWAY AT ~65 MPH WHEN MY VEHICLE DECELERATED DOWN TO 15 MPH. THE VEHICLE WAS STILL RUNNING BUT IT WAS ESSENTIALLY 'DEAD' IN THAT NOTHING HAPPENED WHEN YOU STEP ON THE GAS PEDAL. I WAS LOSING SPEED BY THE SECOND AND COULD NOT MAKE IT OVER TO THE RIGHT LANE DUE TO HEAVY TRAFFIC, SO I WAS LUCKY AND FOUND A SMALL LEFT SHOULD TO PULL OVER ON. IF THERE WAS NO LEFT SHOULDER, I DON'T KNOW WHAT THE OUTCOME WOULD HAVE BEEN. AFTER BEING TOWED TO THE LOCAL FORD DEALER/SERVICE SHOP, IT WAS DETERMINED TO BE AN ELECTRONIC THROTTLE BODY(ETB) WHICH FAILED. FORD REPLACED THE ETB, BUT STATED THE REPLACEMENT ETB WAS THE SAME AS THE ONE WHICH FAILED. THERE WAS NO REASSURANCE THAT THE PROBLEMATIC ETB WAS BEING REPLACED WITH A MORE DURABLE SOLUTION. THE FORD SERVICE SHOP MENTIONED THAT THIS HAS BEEN A MAJOR ISSUE IN 2015 & 2016 FORD EXPLORERS, BUT THERE IS NO OFFICIAL RECALL. AFTER DOING SOME RESEARCH ON MY OWN, I WAS DISTURBED TO FIND THAT THERE HAVE BEEN MANY RECENT ETB FAILURES ON FORD EXPLORERS. CONSIDERING THIS ISSUE RELATES DIRECTLY TO THE ABILITY OF THE DRIVER TO ACCELERATE, IT IS A MAJOR SAFETY HAZARD. IF THE DRIVER LOSES THE ABILITY TO MOVE OFF THE ROAD, THERE MANY ACCIDENTS WAITING TO HAPPEN.
Jun 20, 2016
FAULTY THROTTLE BOTTLE. WHILE CRUISING SLIGHTLY UNDER HIGHWAY SPEEDS THE VEHICLE ENTERED "LIMP MODE" WHICH PREVENTS THE MAINTAINING OF SPEEDS CREATING A SAFETY HAZARD. NEW THROTTLE BODIES ARE ON "INDEFINITE" BACK ORDER WHICH IN MY OPINION CORRELATES WITH A SYSTEMIC, ONGOING ISSUE.
Apr 21, 2016
ENGINE AND ENGINE COOLING,STRUCTURE,TIRES
1 complaint
The contact owns a 2016 Ford Explorer. The contact stated that while driving in traffic, a trim piece detached from the vehicle. The TPMS and check engine warning light were illuminated. The dealer sent a tech to the contact’s place of employment, but the tech was unable to complete the recall repair due to the bolt not being available. The contact had received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure). The contact stated that the turbocharger had been replaced on three occasions. Upon investigation, the contact had linked the failure to NHTSA Campaign Number: 16V925000 (Engine and Engine Cooling). The contact called the local dealer, who confirmed the parts for the recall repairs were not yet available. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and a complaint was filed, but no assistance was provided. The failure mileage was unknown.
Oct 06, 2025
VEHICLE SPEED CONTROL,FUEL SYSTEM, GASOLINE
1 complaint
The contact owns a 2016 Ford Explorer. The contact stated that while driving 70 MPH, the vehicle unintendedly started to decelerate. Additionally, while depressing the accelerator pedal, the brakes unintendedly engaged. The “Scheduled Maintenance” light was illuminated. The contact pulled over to the side of the road and depressed the accelerator pedal seven times, and the vehicle started to operate as intended. The contact stated that a dealer was contacted. The vehicle was taken to the dealer and was test-driven, and the dealer informed the contact that the vehicle was operating as designed. The contact related the failure to the results of a Google search on the throttle body. The vehicle was not repaired. The manufacturer was notified of the failure and opened a case. The approximate failure mileage was 136,000.
Aug 29, 2025
STRUCTURE,TIRES
1 complaint
The contact owns a 2016 Ford Explorer. The contact stated while driving 55-65 MPH, the exterior A-pillar applique trim detached from the front windshield. The tire pressure system fault warning light was illuminated. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact called two other local dealers Jenkins Lincoln of Crystal River Service (2440 US-19, Crystal River, FL 34428) and J. Allen Ford Service (9274 US 49, Gulfport, MS 39503), but the vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 97,000. VIN tool confirms parts not available.
Jul 16, 2025
SEAT BELTS,STRUCTURE
1 complaint
The contact owns a 2016 Ford Explorer. The contact stated that the exterior A-pillar trim had detached from the front windshield and the metal studs were showing. The contact stated that the seat belt light warning light was illuminated. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 50,000. VIN tool confirms parts not available.
Jun 24, 2025
PARKING BRAKE,ENGINE AND ENGINE COOLING
1 complaint
The contact owns a 2016 Ford Explorer. The contact stated that upon engaging the parking brake, the parking brake failed to remain engaged. Additionally, the contact stated that upon activating the A/C, the A/C was blowing hot air. The vehicle was taken to a Mazda dealer, where it was diagnosed that there was a blockage in the engine block heater. The dealer informed the contact that no authorization was provided to repair the failure. The vehicle was not repaired. The dealer referred the contact to the NHTSA Hotline for assistance. The manufacturer was not notified of the failure. The failure mileage was unknown.
Jun 12, 2025
STEERING,STRUCTURE
1 complaint
The contact owns a 2016 Ford Explorer. The contact received notifications of NHTSA Campaign numbers: 24V031000 (Structure) and 25V347000(Structure); however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. Additionally, the contact stated that while driving 40 MPH and making a right turn, the vehicle lost power steering functionality. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that the steering wheel had failed. The vehicle was not repaired. The manufacturer was notified of the failure but denied assistance in covering the cost of the repair. The failure mileage was approximately 105,000. VIN tool confirms parts not available.
Jun 12, 2025
STEERING,VEHICLE SPEED CONTROL,TIRES
1 complaint
The contact owns a 2016 Ford Explorer. The contact stated that while driving at various speeds, while attempting to make a left or right turn, there was a popping sound coming from the steering wheel. Additionally, while driving on the highway at 70 MPH, the vehicle failed to exceed 70 MPH. The contact stated that there was an abnormal burning odor entering the cabin of the vehicle with the TPMS warning light illuminated. The local dealer was not contacted. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 121,000.
May 05, 2025
VISIBILITY,STRUCTURE,ENGINE
1 complaint
The contact owns a 2016 Ford Explorer. The contact stated that water had entered the vehicle, and the inside of the windshield was freezing. There was an abnormal sound coming from the vehicle. The contact stated that the defrosted was inoperable. Additionally, the TPMS warning light was illuminated. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehicle was towed to the local dealer, who blew out the tubes and replaced the water pump. The vehicle was repaired, but the failure recurred. The contact stated that after a rainstorm, water entered the vehicle from the sunroof. The vehicle was taken back to the dealer, where it was diagnosed that the sunroof track needed to be replaced. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The manufacturer referred the contact to the NHTSA Hotline. The approximate failure mileage was 77,000. VIN tool confirms parts not available.
Apr 10, 2025
SEATS,VISIBILITY/WIPER
1 complaint
Driver seat moves all the way forward on its own and the side view mirror moves out of range. This has happened while in the seat and car running. It happens intermittently. It scares the heck out of you and pushes you all the way into the steering wheel which makes it impossible to steer. You have to be quick in order to stop it and because it startles you when it happens the reaction time is not immediate. Very scary indeed!
Mar 28, 2025
STEERING,ELECTRICAL SYSTEM,UNKNOWN OR OTHER
1 complaint
I was driving 55mph (speed limit) down a curvy country road when the steering wheel became stiff and wouldn’t turn. A red light flashed and said I had lost steering. I was barely able to get stopped before going of a steep embankment. I was stoped in a dangerous spot with no way get out of oncoming traffic. My vehicle flashed a yellow light that said Terrain management system failure. No only was my life risk everyone that traveled down that road that morning. This included a school bus full of children and several other people that were trying to make it so work just like me.
Jan 18, 2025
STEERING,ELECTRICAL SYSTEM,FORWARD COLLISION AVOIDANCE
1 complaint
Randomly, the power steering, ABS, and traction control went out on my car. There are thousands of others with this issue and previous years of this car have already had a recall relating to this issue.
Dec 26, 2024
SUSPENSION,WHEELS
1 complaint
The contact owns a 2016 Ford Explorer. The contact stated that while driving at 55 MPH exiting a residential area. The front wheel axle came apart. The contact's husband removed the shocks. The contact was able to drive the vehicle to her residence. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 17E048000 (Wheels, Suspension). The contact called the local dealer, who confirmed there were no associated recalls. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 220,000.
Nov 14, 2024
EXTERIOR LIGHTING,STRUCTURE
1 complaint
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving approximately 30 - 40 MPH, the windshield side A-trim panel detached from the vehicle. The contact stated that the following day the passenger’s side trim and two clips had detached causing the failure. The trim on the bottom of the front and rear doors between the front and rear wheels had become loosened as well. The contact stated that there was a film on the headlights causing the headlights to not illuminate properly. The contact used WD-40 on the headlamps to remove the film for proper illumination. The vehicle was taken to the dealer who inspected the vehicle and removed the trim cover, as instructed by the manufacturer, to determine if the windshield mounting plate, was an older version. Based on the inspection, the dealer determined that the vehicle had failed and there was no need for the part mentioned in the remedy to be used for a repair. While completing the inspection the trim cover had to be removed and the trim cover became loosened, causing further damage with other trim panels detaching from the vehicle. The contact informed the dealer, and the dealer offered to secure the trim with tape. The dealer also advised the contact to use duct tape to further secure the area. The contact stated that the following day the tape had raised up. The contact called BP Ford of Long Beach (2950 N Bellflower Blvd, Long Beach, CA 90815) and was informed that the part could be ordered to complete the recall repair. The dealer informed the contact that the trim could be replaced; however, the recall remedy part was not yet available. The headlight and lower trim on the body of the vehicle had not been replaced. The manufacturer was made aware of the failure. The failure mileage was 83,000. VIN tool confirms parts not available.
Sep 25, 2024
STEERING,POWER TRAIN,ELECTRICAL SYSTEM
1 complaint
Randomly whilst driving, my dash had multiple error messages pop up and my power steering went out completely. The error messages were as follows: Service AdvanceTrac, Terrain Management System Fault, Hill Start Assist Not Available, & Power Steering Assit Fault. This keeps happening intermittently, while I am driving. This causes a serious safety issue, for my steering wheel to lock up while I am driving! I did get the codes for the errors and they are as follows: U0420-41, C0051-67, U0151-00, U0131-00. My ABS system failed check, as well. This is a known issue with Ford vehicles, as there have already been recalls for previous models. According to [XXX]: "Ford has recalled earlier model year Explorers with power steering problems before. In 2014, Ford recalled certain model year 2011-2013 Ford Explorers, saying these vehicles “may experience an intermittent connection in the electric power steering gear, which can cause a loss of the motor position sensor signal resulting a shut down of the power steering assist.” According to Ford, this issue “may increase the risk of a accident.” In 2015, Ford recalled certain model year Ford Fusion, Ford Taurus, Ford Flex, Mercury Milan, Lincoln MKS, Lincoln MKT, and Lincoln MKZ vehicles. According to Ford, these vehicles had “electric power steering assist systems that may shut down as a result of a steering motor sensor fault.” As a result, “[i]f the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, increasing the risk of a vehicle crash”. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Sep 11, 2024
UNKNOWN OR OTHER,BACK OVER PREVENTION
1 complaint
60 mph y se calló 60 MPH and it stopped
Sep 06, 2024
STEERING,FORWARD COLLISION AVOIDANCE
1 complaint
The contact owns a 2016 Ford Explorer. The contact stated while attempting to leave her residence, it was difficult to maneuver the steering wheel. The contact continued to drive the vehicle when several unknown warning lights displayed on the instrument panel. The vehicle was taken to a dealer where it was diagnosed with a power steering rack failure and needed to be replaced. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The failure mileage was 70,000.
Jul 24, 2024
FORWARD COLLISION AVOIDANCE
1 complaint
The contact owns a 2016 Ford Explorer. The contact stated while driving at an undisclosed speed, the "Pre-Collision Assist Unavailable" and "Cruise Control" messages were displayed. There were no warning lights illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the cruise control module; however, the dealer was unable to diagnose a failure with the Pre-Collision assist failure. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 90,000. The VIN was not available.
Jul 19, 2024
ELECTRICAL SYSTEM,STEERING
1 complaint
The contact owns a 2016 Ford Explorer. The contact stated that while making left and right turns on several occasions at various speeds, the parking assist warning light illuminated, and the steering wheel became stiff. The vehicle was taken to an independent mechanic where it was diagnosed that the rack and pinion needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 122,312.
Jun 06, 2024
STEERING,SUSPENSION,LANE DEPARTURE
1 complaint
component or system failed or malfunctioned unavailable for inspection upon he safety of others put at risk Had the problem been reproduced or confirmed by a dealer or independent service center Has the vehicle or component been inspected by the manufacturer representatives or others warning lamps messages other symptoms of the problem prior to the failure, and when didnt first appear What component or system failed or malfunctioned, and is it available for inspection upon request? How was your safety or the safety of others put at risk Has the problem been reproduced or confirmed by a dealer or independent service center component been inspected by the manufacturer,representatives any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear fully report
Jun 03, 2024
VISIBILITY,SEAT BELTS
1 complaint
The contact owns a 2016 Ford Explorer. The contact stated that the sunroof failed to close. The seat belt warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the sunroof motor had failed and needed to be replaced. The vehicle was not repaired. The dealer informed the contact that the parts were on backorder. The manufacturer was not contacted. The failure mileage was approximately 136,000.
May 17, 2024
STEERING,UNKNOWN OR OTHER,SERVICE BRAKES
1 complaint
Unknown Overall something within while driving my truck i had starting hearing a grinding sound while turning and then the steering started to lock up, very unsafe and while my children were going to school had me in panic mode in which i never experience out of all the vehicle ive had and paid off.
May 05, 2024
STEERING,SEAT BELTS,UNKNOWN OR OTHER
1 complaint
This is the problem I'm experiencing, my steering wheel would tighten up when I'm backing up from being part. Then when it comes to me, pulling out and about to drive and I have to make a turn the stand well will tighten up again and make it difficult for me to drive or or to turn go other way. When I took my vehicle in to suburban Ford service Ferndale. I'm looking at the questions for additional details. I wasn't in no accident because of my. There's no fire, no injuries, but it can happen and I don't have to have the mileage at how fast I was going because the stand will would get tight when i'm about this pull off.
Apr 28, 2024
POWER TRAIN,VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE
1 complaint
The transmission began slipping causing poor control at higher speeds using the cruise control or passing gear. Only about 42,000 miles on the vehicle and no financial help from Ford. Service for a new transmission was $7667.11at Dave Sinclair Ford, 7466 South Lindbergh, St. Louis Missouri, 63125. 314-892-2600
Apr 09, 2024
STEERING,SERVICE BRAKES, AIR,ENGINE
1 complaint
The contact owns a 2016 Ford Explorer. The contact stated that while driving at undisclosed speeds, the steering wheel was making an abnormal grinding sound. The ABS, air bags, and check engine warning lights were illuminated. The contact called the local dealer and was informed that the parts were not available to repair the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The approximate failure mileage was 14,000.
Mar 01, 2024
ELECTRICAL SYSTEM,LATCHES/LOCKS/LINKAGES,STRUCTURE
1 complaint
The contact owns a 2016 Ford Explorer. The contact stated while driving 70 MPH, the driver’s side front door panel became loosened due to failed adhesive exposing wiring in the door. The front door lights remained illuminated while the door was closed. The contact stated that the rear door failed to open however, the door ajar light was illuminated. The vehicle was taken to the dealer, and tape was placed on the vehicle however, the failure persisted. The vehicle was taken back to the dealer and the contact was informed that the Keyless entry door panel and actuary for the rear door needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure. The approximate failure mileage was 195,000.
Feb 27, 2024
VISIBILITY,AIR BAGS,STRUCTURE
1 complaint
The contact owns a 2016 Ford Explorer. The contact stated that the air bag warning light was illuminated. The contact stated that there was windy sound coming from the front passenger's side door while driving. Additionally, the contact stated that there was water accumulated between the front driver's side door and the body of the vehicle, which caused water to pour inside the vehicle while opening the door. The contact also noticed that water was leaking from the driver's side of the windshield during inclement weather. The contact stated that the vehicle made an abnormal popping sound while making a left turn. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 104,000.
Feb 23, 2024
SUSPENSION,UNKNOWN OR OTHER,ENGINE
1 complaint
Subject: Urgent Vehicle Safety Complaint Regarding Defective Water Pump in Ford and Lincoln Vehicles I am writing to bring to your attention a critical safety concern affecting numerous Ford and Lincoln vehicles worldwide, specifically those equipped with Cyclone (Duratec) engines. The issue at hand revolves around a defective water pump, which has manifested in various models, including but not limited to: - Ford Edge - Ford Explorer - Ford Flex - Ford Fusion - Ford Taurus - Lincoln Continental - Lincoln MKT - Lincoln MKX Owners of these vehicles are experiencing a significant and alarming risk of stalling in traffic, posing a severe threat to both driver and passenger safety. The potential consequences, including the increased likelihood of accidents and fatalities, demand immediate attention and action from Ford Motor Company who has been sued multiple times and is avoiding to respond to the judgements against them trying to use any excuse not to pay. It is imperative to address this widespread concern promptly, as the safety and well-being of Ford and Lincoln vehicle owners are at stake. I urge your organization to conduct a thorough investigation into the defective water pump issue, implement a comprehensive recall, and provide a reliable solution to rectify the problem. Your commitment to prioritizing the safety of consumers is paramount, and I trust that Ford Motor Company will take swift and decisive action to remedy this situation. By addressing this issue promptly, you not only ensure the protection of current owners but also uphold the reputation of Ford and Lincoln in the automotive industry. It's impossible to say that it is a mere coincidence that thousands of Ford vehicles have the same defect with exactly the same engine and symptoms. Thank you for your immediate attention to this matter, and I anticipate a proactive response that prioritizes the safety and satisfaction of Ford and Lincoln vehicle owners.
Feb 14, 2024
UNKNOWN OR OTHER,LATCHES/LOCKS/LINKAGES
1 complaint
The automatic tailgate in my Explorer Sport accelerates when closing creating a serious amount of force that could kill a small child or even an adult if striking them in the head or neck. I'm shocked that this hasn't been a recall issue for Ford vehicles because of the amount of speed and force this tailgate is generating. It hit my wife [XXX] ) in the head unexpectedly a couple of months ago when she was unloading groceries from the back of the car. Until then the tailgate functioned normally. I took the car to the dealer in Santa Monica and they said they did not see any safety issues but instead said I'd have to pay a couple of thousand dollars to replace the motor. This makes no sense since the motor is hyper functioning and it's more likely a failed safety sensor or actuator that's causing the motor to accelerate the tailgate closure. The internet has a method to reset the sensor by removing and then replacing the fuse, but I do not believe the dealer attempted that process. This is a severe safety issue that Ford should immediately address and fix. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Nov 27, 2023
AIR BAGS,LANE DEPARTURE,BACK OVER PREVENTION
1 complaint
Back up camera went out and later came on. Today we have been driving the last hour with airbag indicator on. Camera incident was 10-29-2023.
Nov 02, 2023
ELECTRICAL SYSTEM,STRUCTURE,UNKNOWN OR OTHER
1 complaint
The power liftgate stop working. The liftgate light on dashboard shows liftgate open and the power liftgate does not work open nor closes.
Sep 13, 2023
LATCHES/LOCKS/LINKAGES
1 complaint
The contact owns a 2016 Ford Explorer. The contact stated that on multiple occasions, the door locks failed to open. The contact stated that the rear driver’s and passenger’s side doors failed to unlock as needed. The contact used the key fob remote to attempt to unlock the doors, but the doors failed to unlock. Additionally, the contact stated that she attempted to manually unlock the doors, but the doors failed to unlock from the inside or the outside. The vehicle was taken to the dealer where it was diagnosed that the door lock mechanism had failed and needed to be replaced. The vehicle was repaired; however, the failure recurred. The contact stated that the front driver’s side door failed to unlock, and the lock was stuck in the locked position. The contact attempted to manually unlock the front driver’s side door, but the door failed to unlock. The contact stated that she was concerned that during an emergency, she would be stuck inside or outside of the vehicle. The vehicle was taken back to the dealer where it remained. The vehicle had not yet been repaired. The manufacturer was notified of the failure and the contact was advised to contact the NHTSA Hotline. The failure mileage was approximately 141,000.
Aug 31, 2023
STEERING,SUSPENSION,SEAT BELTS
1 complaint
#1-My rear passenger seatbelt is being cut by some thing down inside of the back seat where the belt is retrieved. This belt is getting more cuts as it is being used since that is where my Grandson now sits. It was not used prior to me having to pickup my Grandson. This is very concerning !!! #2 My drivers side front windshield weather stripping keep popping out and is now blown off, very scary. #3 Just last week I started to hear some popping noise in the front suspension, but could not tell what it was coming from. Just yesterday while making a right hand turn the front suspension and the steering locked up. I was able to turn it back straight after a few seconds as the steering wheel had locked to the right. Praise God there were 3 lanes and I was able to make the correction with out incident.
Aug 21, 2023
STEERING,POWER TRAIN
1 complaint
While driving on the interstate and set MPH were 55, a series of notifications popped up on my dashboard. One stated “Steering assist fault repair required.” After I hit Ok to clear the screen my steering wheel tightened up and locked and caused me to almost crash into another family. We were able to move it to a safe location.
Jul 02, 2023
ELECTRICAL SYSTEM,ENGINE,FORWARD COLLISION AVOIDANCE
1 complaint
My touch screen isn’t working properly and I have brand new converters in there is smoke coming out of my tail pipes, also I have to jump my vehicle every time I want to go somewhere.
Feb 25, 2023
SUSPENSION,AIR BAGS,STRUCTURE
1 complaint
The contact owns a 2016 Ford Explorer. The contact stated that while driving at various speeds, a rattling noise was heard underneath the vehicle. Additionally, water was entering the vehicle from the roof rack. No warning lights were illuminated. The contact received notification of NHTSA Campaign Number: 20V675000 (Suspension), 21V537000 (Suspension), and 21V316000 (Structure). The contact stated that after taking the vehicle to a local dealer for the recall repairs, he was made aware that there was no mechanic available to complete the needed recall repairs. The contact stated that he was rescheduled on two other occasions. The vehicle was not repaired, and the contact stated that while driving at an undisclosed speed, the air bag warning light illuminated. The manufacturer was made aware of the failure. The approximate failure mileage was 70,000. Parts distribution disconnect.
Feb 24, 2023
STRUCTURE,VISIBILITY
1 complaint
The contact owns a 2016 Ford Explorer. The contact stated while driving at an undisclosed speed, the front driver’s and passenger’s side window trims detached from the window and struck the side mirror. The vehicle was not diagnosed or repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 79,000.
Feb 02, 2023
STRUCTURE,FUEL/PROPULSION SYSTEM
1 complaint
Every since I bought this vehicle back in December 2016. I've had major problems that consist of the battery lasting a year an half. In 2018, Ford had it for two weeks due to a major problem that they repaired but never told me what the issue was. Still, to this day, I don't know what they repaired. In 2021, My water pump went out, something is wrong with he fuel injection that may be causing the engine light to be on. Every year since 2016 there's been something going wrong with my Explorer, including the radio panel/cameras monitor. Last year, 2022, I was driving down the highway when my windshield trim panels flew off! I thought it was something from another car until I stopped and realized, my windshield didn't have a cover on the driver side. I'm hoping I didn't caused harm or almost caused harm to any drivers behind me! Nonetheless, since my incident, I have noticed other Explorers missing a windshield cover.
Feb 02, 2023
ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM
1 complaint
The contact owns a 2016 Ford Explorer. The contact stated that while the vehicle was at the dealer for Customer Satisfaction Program: 21N01 (High Speed Fan Motor Relay) the dealer diagnosed that the water pump was faulty, causing the air conditioner fan to fail to deactivate. The dealer declined to perform the repair because the vehicle was out of warranty. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was 41,785.
Dec 22, 2022
STEERING,SUSPENSION,POWER TRAIN
1 complaint
I felt a thumping when turning the steering wheel and took it to the dealership who kept it for two days to attempt to replicate the same noise but they were unable to reproduce or replicate. Two or maybe three months later, the thumping noise turned into a clicking noise. Again, I immediately took it to the Ford dealership and fortunately a mechanic was still on duty. They test drove the vehicle and heard the same noise. They ask if I could leave the vehicle for more testing with their suspension specialist and they will contact me the next day. The next day they contacted me and I was told 'this is a common problem and Ford is aware of issue but has not issued a recall'. Concerned about the comment I took it to a second Ford dealership. The second dealership kept it for a day and of course they could not replicate the thumping or clicking sound. They even inspected the steering/wheel components but found nothing. Worried, I did some additional research and found this website with other people complaining about the same issue https://www.carcomplaints.com/Ford/Explorer/2016/steering/steering-rack_and_pinion.shtml I even found a few YouTube videos addressing the same problem. October is here and winter is about to set in and my vehicle is still thumping and clicking. I am driving the vehicle but concerned I am putting my safety and the safety of others at risk. Based on the information I found, it is clear that I am not the only one with this issue.
Oct 05, 2022
STEERING,SUSPENSION,ELECTRICAL SYSTEM
1 complaint
My rack and pinion steering column and power steering pump went out causing a hefty cost to replace and it is starting to fail again creating hazardous conditions while driving. I do believe there is a steering issue in these models. Also my power lift gate in the back closes without stopping automatically while I’m loading the rear or unloading. There is NO STOPPING SAFETY SENSOR, I HAD THE BACK CLOSE ON ME MULTIPLE TIMES AND ALMOST CRUSH ME. there is no safety sensor to stop the power lift gate from closing on you, I have had to crawl in my rear end to avoid being crushed by my liftgate! This is not safe!
Jan 20, 2022
FUEL SYSTEM, OTHER
1 complaint
Fuel pump fail
Jan 16, 2022
EQUIPMENT
1 complaint
NY CAR OVERHEATED AND SPILLED ALL THE COOLANT DUE TO THE ENGINE BLOCK HEATERS IT HAS. I TOOK IT FOR AN INSPECTION AND THEY TOLD ME THESE ARE VERY DANGEROUS AND NEED TO BE CHANGED ASAP, I CALLED THE DEALER AND THEY TOLD ME MY CAR DOES NOT HAVE THIS RECALL AND THEY WANT TO CHARGE ME WHEN CLEARLY IT IS THE EXACT PROBLEM WITH RECALL # 16S14 FROM FORD. I NEED THIS FIXED ASAP AT NO CHARGE TO ME AS IT IS FORDS PROBLEM. I NEED MY CAR BACK TO GET TO WORK PLEASE
Aug 03, 2021
STEERING,FORWARD COLLISION AVOIDANCE,LANE DEPARTURE
1 complaint
WENT TO THE BEACH THIS PAST SATURDAY AND AS I WAS PULLING INTO THE TURNING LANE FOR THE STATE PARK AND ALARM WENT OFF SAYING DRIVE ASSIST CONTROL FAILURE, AND NUMEROUS THINGS THAT NO LONGER WORK, SINCE THEN THERE HAS BEEN NO POWER STEERING AND IT WAS A MIRACLE WE GOT IT HOME WHICH WAS AN HOUR AND A HALF AWAY, HAD THIS HAPPENED WHILE GOING FASTER THEN I COULD OF LOST CONTROL OF THE VEHICLE, AND I WAS GOING ABOUT 10 MPH WHEN IT ALARMED. THE PICTURES SHOW WAS ALERTS EVERY TIME THE VEHICLE IS STARTED NOW. THIS MORNING THE STEERING WHEEL WAS NEAR IMPOSSIBLE TO MOVE SO MY GIRLFRIEND WHO DRIVES THE EXPLORER HAS TO USE THE BACK UP CAR THAT CAN'T HOLD ALL OF OUR KIDS.
Mar 15, 2021
SUSPENSION,UNKNOWN OR OTHER
1 complaint
CAR WENT IN FOR RECALL NHTSA #20V675 AND DEALER INSPECTED VEHICLE AND INFORMED US, IT HAS FAILED INSPECTION AND WILL REQUIRE REPLACEMENT. THEY HAVE PARTS QUOTED AT 4-6 WEEKS OUT AND WE ASKED ABOUT A RENTAL VEHICLE AND WERE INFORMED THAT IT WOULD NOT BE COVERED. WE ASKED IF THE VEHICLE WAS SAFE TO DRIVE AND THEY WILL NOT STATE IT IS SAFE TO DRIVE, SO THEREFORE WE CANNOT DRIVE IT. CONTACTED FORD CUSTOMER SERVICE AND WERE INFORMED OUR RENTAL REQUEST WAS DENIED AND THEY WILL NOT SAY THE CAR IS SAFE TO DRIVE. WE CANNOT BE WITHOUT A CAR FOR 6 WEEKS AND CANNOT AFFORD A RENTAL FOR THAT AMOUNT OF TIME. FORD SHOULD COVER RENTAL WHEN PARTS ARE NOT AVAILABLE.
Jan 11, 2021
VEHICLE SPEED CONTROL,EQUIPMENT
1 complaint
USING A PEDAL COMMANDER PC18 BLUETOOTH "THROTTLE ENHANCER" IN AN EMERGENCY VEHICLE EQUIPPED WITH A VHF MOBILE TWO-WAY RADIO. THE RADIO TRANSMITS AT 50W AND IS INSTALLED BY A PROFESSIONAL EMERGENCY VEHICLE UPFITTER PER MANUFACTURERS INSTRUCTIONS. WHEN TRANSMITTING IN THE 156MHZ RANGE THE PEDAL COMMAND CONSISTENTLY AND UNEXPECTEDLY CAUSES THE VEHICLE TO BEGIN ACCELERATING WHEN IN DRIVE, AND INCREASING THE RPM OF THE ENGINE IN PARK. THE ACCELERATION CONTINUES AS LONG AS THE USER IS TRANSMITTING ON THE TWO-WAY RADIO. AS SOON AS THE TRANSMISSING ENDS THE VEHICLE GOES BACK TO IDLE OR RPMS CONSISTENT WITH THE PEDAL POSITION. THESE SYMPTOMS GO AWAY AS SOON AS THE PC18 IS REMOVED. THIS ISSUE WAS ALSO EXPERIENCED BY OTHER USERS WITH PC18 AND RADIOS THAT TRANSMIT IN THE MID 150MHZ RANGE.
Dec 31, 2020
STEERING,VISIBILITY/WIPER
1 complaint
THE STEERING WHEEL AT TIMES WHEN EVEN MAKING A SLIGHT TURN POPS BACK AND SHAKES. RESTRICTING THE TURN THE WIPERS HAVE NOW MULTIPLE TIMES IN RAIN STOPPED IN THE UPRIGHT POSITIONS CAUSING A GRAVE DRIVING HAZARD
Dec 30, 2020
STEERING,ENGINE,FUEL/PROPULSION SYSTEM
1 complaint
THE VEHICLE WITHOUT WARNING , JUST SHUTS OFF. EVEN WHILE GOING 65 MPH ON A HIGHWAY. IF YOUR LUCKY, YOU CAN COAST OFF THE HIGHWAY BEFORE YOU ARE HIT . FORD REFUSED TO FIX EVEN THOUGH UNDER WARRANTY. SO I HAD TO SELL IT SO I WOULDN'T BE KILLED. HUNDREDS IF NOT THOUSANDS HAVE COMPLAINED ABOUT THE SAME THING.
Dec 04, 2020
STEERING,AIR BAGS
1 complaint
WHEN BACKING OUT OF MY DRIVEWAY AND TURNING SLOWLY THERE IS A POPING NOISE AND MY STEERING WHEEL LOCKED UP MULTIPLE TIMES. BEFORE THIS I SPENT 1000 BUCKS TO GET THE WIRING HARNESS FOR AIR BAGS REPLACED. NONE OF THEM WORK FORD WOULD NOT COVER IT BECAUSE THERE IS NOT A RECALL.
Nov 19, 2020
ELECTRICAL SYSTEM,AIR BAGS,SEATS
1 complaint
ON AUGUST 20, 2020, MY VEHICLE HAD LAST BEEN DRIVEN AROUND 12 NOON. IT SAT IN THE DRIVEWAY WITH ALL OF US HOME. MY SON WENT TO GET IN THE VEHICLE AROUND 6:30 PM. SMOKE POURED OUT, THE SEAT WAS SMOLDERING AND FLAMES CAME UP. WE COULDN'T PUT THE FIRE OUT WITH EXTINGUISHER. FIRE DEPARTMENT PUT HOSE ON SEAT. FIREMEN STATED THEY SEE THIS OFTEN WITH HEATED/AIRCONDITIONED SEATS THAT MALFUNCTION AND BURN UP OR CAUSE FIRE. FIREMEN STATED THEY COULD TELL THE WAY IT LOOKED "LIKE ALL THE OTHER HEATED /AIR CONDITIONED SEATS THAT IGNITE THAT THEY SEE OFTEN". INSURANCE COMPANY SAYS CAR IS TOTALED SINCE HOSE WAS PUT ON IT. FORD WILL NOT WORK WITH ME. NO ONE LEFT ANYTHING BURNING IN THE SEAT OR SMOKED IN THE CAR. I BELIEVE THE CAR HEATED/AIR CONDITIONED SEAT MALFUNCTIONED AND FORD SHOULD HELP. I HAD PURCHASED BUMPER TO BUMPER WARRANTY FROM DEALERSHIP. WARRANTY COMPANY SAYS IF A CAR CATCHES FIRE, WARRANTY IS VOIDED, EVEN IF CAR MALFUNCTIONED CAUSING THE FIRE. INSURANCE COMPANY IS TRYING TO PAY AS LEAST AMOUNT AS POSSIBLE. THIS WAS A WELL CARED FOR, VERY NICE CAR. I BELIEVE IT MALFUNCTIONED. FORD MOTOR COMPANY SENT ME A LETTER SAYING THEY HAD THE DEALERSHIP TAKE PICTURES, AND THEY FEEL IT HAD SOMETHING LEFT BURNING ON THE SEAT. NO ONE LEFT ANYTHING BURNING ON THE SEAT. IN THE LETTER FORD MOTOR COMPANY SENT ME BY EMAIL, THEY STATE THEY INSPECTED THE CAR. THEY NEVER CAME TO SEE THE CAR IN PERSON. THEY ONLY HAD THE SERVICE STAFF TAKE PICTURES. THE CAR WAS SITTING IN THE DRIVEWAY ALL AFTERNOON. I ALSO BACKED OUT OF THE DRIVEWAY IN MY SUBARU AT 5:00 PM AND DID NOT SMELL OR SEE SMOKE AS I LEFT.. THE PASSENGER SEAT THAT IGNITED ITSELF HAD A STACK OF BUSINESS PAPERS AND SOME SOCCER GEAR THAT COULD HAVE OVERHEATED IF THE SEAT WAS MALFUNCTIONING TOO. THE SEAT IGNITED BY ITSELF. AS A CONSUMER I DESERVE TO BE ASSISTED. I WOULD LIKE THE CAR REPAIRED OR REPLACED W/SIMILAR CAR.*DT CONSUMER STATED VEHICLE WAS TOTALED AND SETTLEMENT WAS OFFERED BY THE INSURANCE COMPANY. VEHICLE WAS TOWED TO THE DEALERSHIP. *JB
Nov 11, 2020
SUSPENSION,WHEELS,UNKNOWN OR OTHER
1 complaint
TWO SEPARATE FAILURE WITHIN A FOUR DAY TIME SPAN. COMPANY SOLD ME THE VEHIXAL SAID IT WAS A TIE ROD AND FIXED THE RIGHT PASSENGER REAR WHEEL. THE VEHICAL WAS REAL EASED TO ME TODAY WITH THE UNDERSTANDING THAT THE REAR SUSPENSION WAS FULLY REPAIRED. I HAD A HIGH SPEED ACCIDENT AFTER THE LEFT REAR TIR ROD BROKE AT A SPEED OF 80 MPH. DUE TO THE SUSPENSION BREAKAGE, THE CAR WENT OFF THE INTERSTATE AT HIGH SPEED. THE REAR END SUSPENSION HAD COMPLETE FAILURE AND THE AUTO DEALERSHIP RELEASED THE VEHICLE TO ME WITH THE FULL WITH ASSURANCE THE ISSUE WAS FIXED. THIS WAS A VERY SERIOUS INCIDENT WITH A POTENTIAL DEADLY OUTCOME.
Oct 08, 2020
STRUCTURE,SEATS,UNKNOWN OR OTHER
1 complaint
POWER LOCKS GET STUCK ON EITHER LOCK OR UNLOCKED NOT ALLOWING ME TO EITHER LOCK OR UNLOCK THE CAR DOOR ON DRIVER AND BACK PASSENGER DOOR. PLASTIC STRIPPING PANELS ON FRONT DRIVER AND PASSENGER DOORS ARE COMING OFF AND THE PANELS CONNECTED TO THE WINDSHIELD ON BOTH SIDES. POWER SEATS DO NOT HOLD THE MEMORY OF WHERE IT WAS LEFT. THE SEAT GOES ALL THE WAY UP TO THE STEERING WHEEL WHEN MEMORY BUTTONS ARE PRESSED OR IF THE KEYLESS CODE ON THE DOOR IS USED TO UNLOCKED THE CAR. KEYLESS ENTRY WILL UNLOCK WITHOUT TO CODE BEING TYPED IN CORRECTLY. USING THE FIRST THREE NUMBERS CAN UNLOCK THE DOOR. ALL OF THESE THINGS HAPPEN WILL THE CAR IS STATIONARY.
Sep 19, 2020
STEERING,EQUIPMENT
1 complaint
WHILE MAKING TURNS EITHER AT SLOW SPEEDS OR AT A COMPLETE STOP, THE STEERING MAKES POPPING SOUNDS. STEERING WHEEL ALSO LOCKS FOR HALF A SECOND. TOOK VEHICLE TO A SHOP AND WAS ADVISED IT WAS THE RACK AND PINION ON THE FRONT RIGHT TIRE AREA. THE VEHICLE IS A 2016 AND HAS 41K MILES. THIS ISSUE BEGAN MANIFESTING APPROXIMATELY TWO WEEKS PRIOR. ESTIMATED COST TO REPAIR IS $2500. ACCORDING TO VEHICLE FORUMS THIS IS A COMMON ISSUE WITH THIS VEHICLE MAKE AND MODEL.
Sep 04, 2020
POWER TRAIN,SERVICE BRAKES,ENGINE
1 complaint
THIS TRUCK HAS HAD ISSUES SINCE I BOUGHT IT LIKE 5 MONTHS AGO FROM CARMAX WITHIN THAT TIME I REALLY ONLY HAD IT A MONTH REST OF TIME IT HAS BEEN IN THE SHOP I BOUGHT WITH 26K MILES FROM CARMAX ALREADY HAD REBUILT ENGINE BREAKS ROADERS STILL HAVE ENGINE ISSUES NOW TODAY BELT BROKE AND NEEDS TO BE TOWED I SHOULD NOT HAVE TO HAVE DO MANY ISSUES WITH A NEW TRUCK NOT MENTION IF YOU DO NOT SHUT THE TRUNK HARD IT WILL DRAIN THE BATTERY SINCE IT KEEPS THE LIGHTS ON IN THE TRUCK ALREADY HAD TO REPLACE THE BATTERY. THIS TRUCK HAS BEEN A LEMON SINCE DAY ONE AND SHOULD HAVE NEVER BEEN SOLD I FEEL THIS TRUCK IS NOT RELIABLE AND UNSAFE AT TIMES. NOT WORTH THE 26000 I PAID FOR IT. PLUS THE SENSORS GO OFF FOR NO REASON AND NOTHING IS AROUND.
Aug 01, 2020
STEERING,SUSPENSION,UNKNOWN OR OTHER
1 complaint
MY CAR WAS COMPLETELY TOTALED IN AN ACCIDENT ON 10/21/19. I RECEIVED VERY SERIOUS MULTIPLE BRAIN BLEEDS, FACIAL LAC, FACIAL & HEAD FX'S & A SEVERE TBI. MY MOM REC A CONCUSSION, FACIAL LAC CONCUSSION & A FX CLAVICLE. WE STOPPED AT THE STOP SIGN & MOVED TO THE CENTER BETWEEN THE 4 LANES & STOPPED AGAIN & WE WERE HIT BY A LARGE ROLL ON ROLL OFF ROCK CARRYING DUMP TRUCK IN THE MIDDLE OF THE LANES. THE CAR WAS COMPLETELY TOTALED & I WAS IN A COMA & AIRLIFTED TO A TRAUMA CTR APPROX 40 MINS AWAY, BUT I WAS IN RESP ARREST & NOT EXPECTED TO LIVE. IT IS UNKNOWN EXACTLY WHAT CAUSED THE UNSAFE CONDITIONS, HOWEVER I NEVER CROSS STRAIGHT ACROSS THE TRAFFIC & WE HAD BEEN ON A VERY VERY BUMPY INTERSECTION THE FRI BEFORE THE ACC ON MONDAY & THE CAR HAD NOT BEEN DRIVEN SINCE THAT 5 HR TRIP OF EXTREMELY BUMPY ROUGH ROAD CONDITIONS ON INTERSTATE 95 COMING THROUGH PART OF NC, ALL OF SC & PART OF GA.
Feb 04, 2020
STEERING,SUSPENSION,ENGINE
1 complaint
AT SLOW SPEEDS 20 MPH AND LESS THERE IS SIGNIFICANT NOISE WHEN DRIVING OVER BUMPS OR TRANSITIONS. AT VERY SLOW SPEEDS LESS THAN 5 MPH AND TURNING STEERING WHEEL THE STEERING WILL GET STUCK OR HESITATE AND MAKE A CLUNKING OR POPPING SOUND. SEEMS TO BE STABILIZER BAR RELATED. ITS PROGRESSIVELY GETTING WORSE. I ALSO HAVE AN ENGINE SURGING ISSUE AT SLOWER SPEEDS OF 30 MPH OR LESS.
Jan 12, 2020
SUSPENSION,AIR BAGS
1 complaint
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR ILLUMINATED. THE CONTACT WAS CONCERNED THAT THE AIR BAGS COULD DEPLOY AT ANY TIME AND THE SEAT BELTS MAY NOT WORK. IN ADDITION, THE TOE LINK SUSPENSION ALSO FAILED AND THE SEAT BELT WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO MCCLARDY FORD (4400 LANDERS RD, NORTH LITTLE ROCK, AR 72117, (501) 945-1200) WHERE THE MECHANIC STATED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE CONTACT MAY HAVE TO PAY FOR THE REPAIRS. THE FAILURE MILEAGE WAS 39,000.
Aug 09, 2019
ENGINE AND ENGINE COOLING,POWER TRAIN,ENGINE
1 complaint
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT TOOK THE VEHICLE TO STAR DODGE CHRYSLER JEEP RAM (5101 S 1ST ST, ABILENE, TX 79605, (325) 698-2222) TO HAVE THE VLA EMISSION COMPUTER UPDATE COMPLETED. AFTER A FEW DAYS, THE VEHICLE BEGAN TO EXHIBIT A DELAYED RESPONSE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. IN ADDITION, THE VEHICLE DOWNSHIFTED ON ITS OWN SUDDENLY, ESPECIALLY WHILE DRIVING UPHILL. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE VEHICLE WAS AFFECTED BY THE VLA EMISSION UPDATE. AFTER THE UPDATE, THE VEHICLE TENDED TO OVERHEAT AND THE FUEL GAUGE DID NOT ACCURATELY DISPLAY THE CORRECT READING. THE VEHICLE WAS TAKEN TO STAR DODGE A THIRD TIME WHERE IT WAS DIAGNOSED THAT THE EGR WAS THROWING COOLANT INTO THE TURBO. THE CONTACT REACHED OUT TO THE MANUFACTURER AND WAS PROIVDECASE NUMBER: 407224. THE DEALER STATED THAT THE CASE WOULD BE CLOSED BECAUSE THEY COULD NOT REMEDY THE FAILURE. PRIOR TO UPDATING THE VLA, THE CONTACT WAS INFORMED BY THE ECO SYSTEM HOTLINE THAT THE VEHICLE WOULD NOT BE AFFECTED. THE FAILURE MILEAGE WAS 51,000.
Aug 02, 2019
ELECTRICAL SYSTEM,ELECTRONIC STABILITY CONTROL (ESC),ENGINE
1 complaint
2016 FORD EXPLORER - THE BACKUP CAMERA WILL COME ON WHILE TRAVELING DOWN THE HIGHWAY AT 55-60 MPH. WILL CAUSE IT TO LOOSE POWER, THE RPM'S DROP RIGHT BELOW 1000, THE WRENCH SYMBOL COMES ON, AND IT WILL BARELY MOVE DOWN THE ROAD. A SCREEN WILL POP UP ON OCCASION SAYING HILL ASSIST IS UNAVAILABLE. YOU HAVE TO PULLOVER, TURN THE CAR OFF, OPEN THE DRIVER DOOR TO MAKE SURE THE RADIO AND ALL GOES OFF, WAIT EXACTLY ONE MINUTE, AND THEN YOU ARE ABLE TO CRANK THE VEHICLE UP TO BE ABLE TO MOVE. I HAVE TAKEN TO DEALERSHIP, AND ALL THEY SAY IS IT'S A SENSOR INSIDE THE TRANSMISSION, AND ALL THEY CAN DO IS CLEAR THE CODE OUT. THEY SAY THAT IT IS SAYING MY VEHICLE IS TRYING TO ENGAGE IN REVERSE WHILE GOING DOWN THE ROAD. THIS SOUNDS LIKE A HUGE SAFETY ISSUE ESPECIALLY WHEN I HAVE HAD OTHERS SAY THE SAME THING HAS HAPPENED TO THEM AS WELL. I HAVE REACHED OUT TO THE DEALERSHIP IN REGARDS TO MY WARRANTY, BUT I HAVE YET TO HEAR BACK FROM THEM, AND IT HAS BEEN OVER 2 WEEKS. I HAVE ALSO REACHED OUT TO THE SALES REPRESENTATIVE SEVERAL TIMES, AND I HAVE YET TO HEAR FROM HIM. I CONTACTED THEM BECAUSE WHILE LOOKING AT THE PAPERWORK IT SAID IT HAD A LIMITED POWER TRAIN WARRANTY, BUT IT WAS PURCHASED AS A PRE-CERTIFIED USED VEHICLE WITH AN UNLIMITED POWER TRAIN WARRANTY THEY WERE OFFERING FOR VEHICLES WITH LEST THAN 80,000 MILES. I HAVE NOT HAD IT A YEAR YET. I HAVE AN EMAIL FROM THE SALES REP HIMSELF STATING THAT IT IS UNLIMITED. IT WAS PURCHASE IN SEPTEMBER OF 2018.
Jul 27, 2019
POWER TRAIN,ELECTRICAL SYSTEM,UNKNOWN OR OTHER
1 complaint
PROBLEM FIRST APPEARED ON JUNE 3, 2016 WITH ABOUT 10,000 MILES. I WAS DRIVING ON INTERSTATE 95 PAST PHILADELPHIA AIRPORT ABOUT 9:30 AM AT ABOUT 60 MPH. THE VEHICLE HAD BEEN DRIVEN FROM A COLD START FOR ABOUT 20 MINUTES. IT WAS RAINING MODERATELY. THE BACKUP CAMERA SUDDENLY APPEARED ON THE SCREEN IN THE CENTER CONSOLE AND THE TRANSMISSION SHUDDERED SLIGHTLY. I ALSO NOTICED THAT THE DASHBOARD DRIVE INDICATOR, WHICH NORMALLY IS LIT RED WHEN IN DRIVE, WAS WHITE, AS WERE ALL THE OTHER INDICATORS (R, N, ETC). I JIGGLED THE SHIFTER WITHOUT PRESSING THE SHIFTER BUTTON BUT THAT DID NOT FIX THE PROBLEM. THE TRANSMISSION APPEARED TO BE STILL IN DRIVE SINCE THE CAR STILL HAD POWER AND WAS NOT SLOWING DOWN. IT LASTED FOR ABOUT 15 SECONDS AND THEN THE DISPLAY RETURNED TO NORMAL AND THE D INDICATOR RETURNED TO ITS NORMAL RED MODE. ABOUT 30 SECONDS LATER THE PROBLEM RETURNED AND STAYED FOR 10 TO 15 SECONDS AND THEN AGAIN REVERTED BACK TO NORMAL. THIS BEHAVIOR REPEATED ONE OR TWO MORE TIMES IN THE NEXT COUPLE OF MINUTES. AFTER THIS SERIES OF EVENTS THE CAR SEEMED TO BE NORMAL FOR THE REST OF MY 1.5 HOUR TRIP AND HAS BEEN FINE UNTIL AUG 13, 2016 WHEN THE SAME BEHAVIOR HAPPENED AGAIN. THIS COULD BE A SERIOUS SAFETY PROBLEM IF IT GETS WORSE IF FOR NOTHING ELSE THAN IT IS CERTAINLY A DISTRACTION AND MAY RESULT IN TRANSMISSION DAMAGE AND LOSS OF CONTROL. I DID TALK TO THE SERVICE MANAGER AT MY FORD DEALER (SHERIDAN FORD, RT 2 KIRKWOOD HIGHWAY, WILMINGTON DE) ON JULY 21, 2016 WHEN I WAS GETTING AN OIL CHANGE AND I DESCRIBED THE FIRST INCIDENT. HE DID NOT SEEM VERY CONCERNED. HE SAID THAT THEY HAD NEVER HEARD OF THAT HAPPENING BUT DID NOT HAVE ME WRITE ANYTHING DOWN. I TOLD HIM THAT IF IT HAPPENED AGAIN, I WOULD CONTACT FORD AND THE DEALER. THE PROBLEM HAS OCCURRED 12 MORE TIMES. I HAVE TOLD THE DEALER ABOUT IT EVERY TIME. I HAVE FURTHER TEXT DOCUMENTATION.
Jun 15, 2019
STEERING,SUSPENSION,SERVICE BRAKES
1 complaint
VEHICLE IS EXPERIENCING POPPING NOISES WHEN TURNING THE STEERING WHEEL LEFT OR RIGHT ALSO HAPPENS WHILE BRAKING THE POPPING IS SIGNIFICANT ENOUGH TO FEEL IN THE STEERING WHEEL AS WELL AS IN THE FLOOR BOARDS ON BOTH FRONT PASSENGER AND DRIVER. THE STEERING WHEEL HAS EXHIBITED EXTREME VIBRATION ENOUGH TO MAKE THE OUTSIDE DRIVER REVIEW MIRROR SHAKE. THE STEERING WHEEL HAS ALSO BEEN STUCK IN THE LEFT TURNING POSITION TWICE WHILE TRYING TO STRAIGHTEN WHEELS BACK OUT.
Jun 15, 2019
SEATS,UNKNOWN OR OTHER
1 complaint
THE LOCATION OF THE CONTROLS FOR THE THIRD ROW SEATS IS A PROBLEM. WHEN THE SEATS ARE DOWN, THE BUTTONS FACE THE INTERIOR OF THE CAR AND CAN BE BUMPED BY CARGO. ONCE THE SEATS START TO MOVE, THERE IS NO WAY TO STOP THEM. THIRD, THE LAST TIME WE PUT THE THIRD ROW DOWN, THEY WOULD NOT RETURN TO THE SEAT POSITION WHEN WE PUSHED THE BUTTON. I LOOKED THROUGH THE CAR GUIDE FOR A MANUAL OVERRIDE, BUT THE STRAP THAT IS ON SOME CAR SEATS, IS NOT ON THE 3RD ROW SEATS. THE VEHICLE HAS BEEN IN PARK, AND THE ENGINE OFF, WHEN THIS HAPPENED, AND WHEN WE TRIED TO REMEDY THE PROBLEM. BOSCH FORD IN TEMECULA HAD NO SUGGESTIONS ABOUT WHAT THE PROBLEM COULD BE, OR ANY PRICE RANGES FOR POSSIBLE REPAIRS.
May 31, 2019
SUSPENSION,SEATS
1 complaint
PASSENGER SEAT STUCK ALL THE WAY FRONT WON'T MOVE BACK AND POPPING NOISE WHEN TURNED WHEEL IT'S STRUCK TOWER MOUNTS STRUTS AND FRONT SWAY BAR LINKS
May 23, 2019
STRUCTURE,UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM
1 complaint
ONE MORNING, I BEGAN TO SMELL A SULFUR OR GAS-LIKE SMELL INSIDE THE CAR. I THOUGHT NOTHING OF IT BUT IT PERSISTED FROM 5:00 A.M. -9:00 A.M. MY 7 YEAR OLD SON EVEN SMELLED IT WHEN ENTERING THE CAR. AFTER DROPPING HIM OFF AT SCHOOL I DROVE TO DEALERSHIP TO GET IT INSPECTED. DURING THAT DRIVE, WITH THE WINDOWS CRACKED, I BEGAN TO FEEL A DULL HEADACHE, DIZZINESS AND MUSCLE WEAKNESS. ONCE I DROPPED MY CAR OFF FOR INSPECTION AND WAS OUT OF THE CAR I DIDN'T FEEL ANY BETTER AND MY HEADACHE AND WEAKNESS GOT WORSE. MY WIFE TOOK ME TO THE ER OUT OF PRECAUTION AND AFTER BLOODWORK WAS TAKEN, I WAS CONFIRMED TO HAVE HAD CARBON MONOXIDE POISONING. I AM A NON-SMOKER AND MY COHB LEVELS WERE TWICE THAT OF A NON-SMOKER : 3.8% IT WAS RAINING OUT SO I COULD NOT UNROLLI WINDOWS AS MUCH AS I WANTED TO. I WAS NOT DRIVING WITH THE A/C ON, WAS NOT SITTING IDLE. MINIMUM SPEED WAS 5-10 MPH AND MAX SPEED WAS 70 MPH FORD IDENTIFIED THE SMELL AS A FAILING PTU BUT CLAIMED THERE WAS NO CO PRESENT AFTER DRIVING THE VEHICLE WITH A CO SENSOR INSIDE THE CAB. I HAVE OWNED THE VEHICLE FOR 32 MONTHS WITH NO ISSUE BUT I CANNOT IGNORE THAT I DID IN FACT HAVE CARBON MONOXIDE EXPOSURE IMMEDIATELY FOLLOWING THE EXISTENCE OF THE STRONG SULFUR SMELL SHOWING UP. I AM NOT CONVINCED CARBON MONOXIDE GETTING INSIDE THE VEHICLE WILL NOT HAPPEN AGAIN.
Apr 17, 2019
STEERING,SEAT BELTS,VEHICLE SPEED CONTROL,ENGINE
1 complaint
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE SHUT DOWN WITHOUT WARNING. THE VEHICLE WAS TOWED TO ROUNTREE FORD (318-798-3673, LOCATED AT 8770 BUSINESS PARK DR, SHREVEPORT, LA 71105) WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE FAILURE WAS REPAIRED. AFTER THE REPAIR, WHILE DRIVING AT AN UNKNOWN SPEED, THE SEAT BELT INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO WRAY FORD (318-686-7300, LOCATED AT 2851 BENTON RD, BOSSIER CITY, LA 71111) WHERE THE SEAT BELT HARNESS, BUCKLE, AND COMPUTER MODULE WERE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND OFFERED AN EXTENDED WARRANTY, STATING THAT NOTHING ELSE COULD BE DONE. LATER ON, WHILE DRIVING APPROXIMATELY 70 MPH, THE STEERING LOST POWER. AN UNKNOWN WARNING INDICATOR REGARDING A VISIT TO THE DEALER ILLUMINATED. THE VEHICLE WAS TAKEN BACK TO WRAY FORD WHERE IT WAS DIAGNOSED THAT THE STEERING COLUMN NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS NOT PROVIDED. *TR
Mar 22, 2019
STEERING,UNKNOWN OR OTHER,ENGINE
1 complaint
"TAKATA RECALL "WAS DRIVING SLOWLY MAKING TURN AND SUDDENLY COULD NOT MOVE STEERING WHEEL BUT VEHICLE WAS STILL MOVING A BIT .. COULD NOT STOP IT ... COULD NOT GO FORWARD ... NO BACKWARD ....THANKS GOD THAT WAS IN THE ALLEY WITH NO PEOPLE OTHERWISE SOMEBODY WOULD GET HIT... JUST CARS AROUND BUT I DID NOT HIT ANY ...THANKS GOD ...HORIBLE EXPERIENCE ...
Feb 25, 2019
ELECTRICAL SYSTEM,AIR BAGS,VEHICLE SPEED CONTROL
1 complaint
ON A CITY STREET EXPERIENCE LOSS OF ACCELERATING POWER WHILE COMING TO STOP AND CROSSING AN INTERSECTION THE VEHICLE WILL STAR AT A SNAIL PACE BRINGING UP THE SPEED TO 40 MPH ON LIMP MODE SINCE THE VEHICLE SERVICE WRENCH TOOL AND AIR BAG LIGHT UP ON THE DASH BOARD VEHICLE WILL NOT RESPOND PUSHING DOWN ON THE GAS PEDAL.
Oct 29, 2018
WHEELS,UNKNOWN OR OTHER
1 complaint
ORIGINAL HANKOOK FRONT TIRES WERE REPLACED AT ABOUT 10K MILES DUE TO PREMATURE WEAR AND CHUNK OF TIRES PEELING OFF. DEALER STATED THAT IT WAS DUE TO POOR ALIGNMENT. I PAID FOR 2 NEW TIRES. FORD EVENTUALLY REIMBURSED US FOR ONE OF THEM. NOW, 8K MILES LATER THE TIRES ARE JUST AS BAD AS THE ONES THAT WERE REPLACED. THE REAR ONES ARE ALMOST SMOOTH. HANKOOK IS AWARE OF THE PROBLEM AND THEY HAVE INSTRUCTED THE DEALERS TO REPLACE THEM WITH A DIFFERENT MODEL YET MY DEALER WILL NOT DO IT.
Jun 21, 2018
ENGINE AND ENGINE COOLING,FUEL/PROPULSION SYSTEM
1 complaint
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. AFTER THE CONTACT'S WIFE HAD BEEN DRIVING THE VEHICLE FOR APPROXIMATELY TWO WEEKS, AN ABNORMAL ODOR WAS DETECTED COMING FROM THE VEHICLE. THE CONTACT'S WIFE BECAME ILL AND MEDICAL ATTENTION WAS REQUIRED. THE CONTACT WAS INFORMED THAT HIS WIFE HAD CARBON MONOXIDE POISONING AT FOUR TIMES THE NORMAL LIMIT. THE CONTACT WAS INFORMED BY THE MEDICAL DOCTOR THAT THE VEHICLE SHOULD NOT BE DRIVEN. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 79,000.
Jun 18, 2018
POWER TRAIN,VEHICLE SPEED CONTROL,UNKNOWN OR OTHER
1 complaint
IT JOLTS, LUNGES, TRANSMISSION DOESN'T ENGAGE AND SLAMS INTO GEAR HARD IT MAKES YOU FEEL YOU GOT REAR ENDED WITH A BIG BANK. SLOW TO ACCELERATE AND WHEN IT FINALLY DOES IT LUNGES
May 10, 2018
AIR BAGS,WHEELS,UNKNOWN OR OTHER
1 complaint
I WAS DRIVING ON I-94 EAST IN HARRISON TWP, MI ON 3/9/18. I WAS TRAVELING A 70 MPH. I HEARD SOMETHING AND SUDDENLY I AM SAW WHITE ALL AROUND ME LIKE A TUNNEL. AT THAT MOMENT I WAS STILL IN MY LANE. WITHIN SECONDS THE I HAD NO CONTROL OF MY VEHICLE AS THOUGH I HAD NO BRAKES OR STEERING. MY CAR VEERED LEFT HITTING THE CEMENT MEDIAN. THE CAR ROLLED ON ITS LEFT SIDE AND EVENTUALLY FLIPPED BACK UPRIGHT. THERE WERE NO OTHER VEHICLES IN THE ACCIDENT. MY DAUGHTER, 14, AND I WERE IN THE VEHICLE AND WERE TAKEN TO THE HOSPITAL FOR MINOR INJURIES. ON 3/8/18 MY VEHICLE WAS SERVICED AT THE FORD DEALER TO REPLACE A WHEEL BEARING. THE SERVICE MAN MADE A COMMENT ABOUT OUR TIRES WEARING QUICKLY AND SHREDDING. WE PREVIOUSLY REPLACED THEM AT 22,500 MILES. CURRENTLY MY VEHICLE HAD 58,000 MILES. THE VEHICLE WAS A TOTAL LOSS. I TRULY THINK THE ACCIDENT WAS DUE TO A DEFECT IN THE CAR. I CALLED FORD TO REPORT THE INCIDENT AND THEY REFUSED TO INVESTIGATE AND WOULDN'T EVEN SEND BE A LETTER STATING THEY WOULD NOT. THE INSURANCE COMPANY SAID THEY WILL NOT INVESTIGATE THE CAR BECAUSE I WAS THE ONLY VEHICLE SO IT WAS OBVIOUSLY MY FAULT. BOTH COMPANIES REFUSED TO INVESTIGATE. MY INJURIES WERE NOT SUBSTANSIAL ENOUGH FOR ANYONE TO TAKE NOTICE. I THOUGHT THAT IS WHY VEHICLES HAVE BLACK BOXES WERE INSTALLED. I AM FEARFUL 2016 EXPLORER OWNERS OR THE INNOCCENT BYSTANDERS ARE GOING BE HURT OR WORSE IF FORD DOESN'T TAKE THIS SERIOUSLY. I TRULY BELIEVE THE WHITE TUNNEL WAS THE SIDE AIR BAGS DEPLOYED.
Apr 15, 2018
POWER TRAIN,FORWARD COLLISION AVOIDANCE
1 complaint
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE THE VEHICLE WAS IN THE DRIVE POSITION, THE VEHICLE STALLED, ROLLED BACKWARDS, AND CRASHED INTO A TREE. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO SOO MOTORS (391 3 MILE RD, SAULT STE. MARIE, MI 49783, (906) 632-2278) FOR DIAGNOSTIC TESTING. THE CONTACT WAS INFORMED THAT THE VEHICLE PERFORMED AS INTENDED. THE CONTACT WAS ALSO INFORMED THAT THE VEHICLE WAS EQUIPPED WITH HILL BRAKING ASSIST. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND OPENED CASE NUMBER: [XXX]. THE APPROXIMATE FAILURE MILEAGE WAS 24,000. *TT INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT
Mar 21, 2018
TIRES,UNKNOWN OR OTHER
1 complaint
WE PURCHASED A NEW 2016 FORD EXPLORER SPORT 4WD 4DR IN 2016. THE OE TIRES ON THE VEHICLE WERE 4 HANCOOK VENTUS S1 NOBEL 2 TIRES, SIZED 255/50R20. THE DOT RATING IS "5MNC 1A H". AT 13,369 MILES ALL 4 TIRES WERE REPLACE UNDER "WARRANTY". THE FRONT TIRE TREADS WERE "FLACKING/PEELING" . THE WORK WAS DONE BY MATHEWS-CURRIE FORD, 130 TAMIAMI TRIAL NORTH, NOKOMIS FL 34275, ON 5/10/17, RO # 6199123/1. OUR COST FOR THE TIRES WAS $419.62. WE WERE FORCED BY HANCOOK TO REPLACE "LIKE WITH LIKE". AT 23,101 MILES I TOOK THE VEHICLE BACK TO THE SAME DEALER TO HAVE THE OIL CHANGED. THE REPLACEMENT TIRES ARE AGAIN "FLACKING/PEELING." THE DEALER TELLS ME THAT WE WILL HAVE TO REPLACE THEM WITH THE SAME TIRES. THEY ALSO TELL ME THAT THIS A REOCCURRING PROBLEM WITH THIS BRAND OF TIRES. MY BACKGROUND IS THAT OF AN EXECUTIVE IN THE OE AND AFTERMARKET AUTOMOTIVE AND HEAVY TRUCK INDUSTRY. MY EMPLOYERS MANUFACTURED FOUNDATION BRAKES, BRAKE CHAMBERS AND RIDE CONTROL. I KNOW AN UNSAFE SITUATION WHEN I SEE ONE AND THIS ONE IS NOT SAFE. I WAS INVOLVED IN A MAJOR SAFETY RECALL ON RIDE CONTROL AND KNOW WHAT IT CAN COST A COMPANY TO NOT RECOGNIZE WHAT THEIR POTENTIAL LIABILITY CAN BE. I AM NOT COMFORTABLE FOR THE SAFETY OF MYSELF AND MY FAMILY WITH HANCOOK TIRES. MY REQUEST IS THAT SOMEONE FROM YOUR LEGAL STAFF CONTACT FORD'S LEGAL DEPARTMENT AND WARN THEM ABOUT THE FUTURE LIABILITY BEING CREATED FOR THEM BY ONE OF THEIR SUPPLIERS.
Mar 15, 2018
STEERING,ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES
1 complaint
WAS TRAVELING DOWN A CITY SURFACE STREET WHEN ANOTHER VEHICLE TRIED TO BEAT ME TO GETTING ONTO THE SAME STREET I WAS TRAVELING ON MADE A SUDDEN TURN BEFORE I COULD GET TO HIS LOCATION. UPON TRYING TO MANEUVER AND AVOID A COLLISION THE VEHICLE SUDDENLY DID NOT RESPOND TO THE MANEUVER AND INSTEAD VEERED OFF THE ROAD AND CRASHED INTO A RESIDENCE. STEERING FAILED TO FUNCTION AS INTENDED, ABS SYSTEM ALSO FAILED TO FUNCTION PROPERLY. THIS HAS NOT BEEN THE FIRST TIME I GOT INTO A WRECK LIKE THIS WITH THIS VEHICLE. MAKING A SUDDEN TURN IN THIS VEHICLE WILL LIKELY SUFFER SOME SORT OF ACCIDENT, VEHICLE DOES NOT RESPOND LIKE IT SHOULD WITH ALL THEM ELECTRICAL SAFETY FEATURES.
Oct 18, 2017
SUSPENSION,STRUCTURE,ENGINE
1 complaint
SINCE I HAVE PURCHASED THE VEHICLE IN FEBRUARY 16 IT HAS BEEN BACK FOR SERVICE NURMOUS TIMES, STARTING 2 DAYS AFTER DELIVERY! MAJOR COMPLAINT HAS BEEN COOLENT LOSS AND BURNING COOLANT SMELL FOLLOWING WITH A OIL LEAK AT THE SAME TIME. THIS IS A NEW VEHICLE 10 MILES ON IT SHOULDN'T HAVE THESE ISSUES SO I DEMANDED A DIFFERENT VEHICLE, WAS REFUSED DUE TO DEMOGRAPHICS! WELL THE DEALER BRUSHES EVERYTHING OFF AS ALL DO SAY IT'S NORMAL IT HAPPENS, AS TIME PASSES IT GOES BACK TO THE DEALER FOR SAME ISSUE THEY REPLACED A OIL SEAL AGAIN AND COOLANT LOSS AND SMELL IS NORMAL TO THEM, THEY CAN'T FIND ANY ISSUES, I TELL THEM IT'S AFTER LONG DRIVES WELL EACH TIME THEY HAVE IT OVER A WEEK. TO BOOT THEY IGNORE MY COMPLAINT ABOUT THE ROTTEN EGG SMELL I GET ON ACCELERATION! THEY TELL ME IT'S PROBABLY THE GAS I'M USING, MIND YOU THIS IS VERBAL AFTER THE FACT, THEY DID NOT WANT TO PUT IT ON THE WORK ORDER. THEY ORDERED A NEW STEERING WHEEL DUE TO IT PEELING. I WAS ALSO TOLD THAT TECHNICALLY I AM RESPONSIBLE FOR THE DIAGNOSIS IF THEY DO NOT FIND ANYTHING WRONG AND THAT I HAD TO COVER THE TECHS TIME, WELL I HAVE TO TAKE IT BACK IN AGAIN FOR NO COOLANT IN THE OVERFLOW FOUL SMELL COMING FROM THE VENTS AND EXAUST SMELL IN THE CABIN. THE VEHICLE HAS 14900 MI SHOULD NOT HAVE THESE PROBLEMS ESPICALY COSTING WHAT IT DID
Sep 11, 2017
STEERING,SEAT BELTS,STRUCTURE
1 complaint
SINCE PURCHASING THIS VEHICLE IN DECEMBER 2016 I HAVE HAD SEATBELT RETRACTABLE MECHANISM IN THE THIRD ROW REPLACED; I HAVE HAD THE NAVIGATION SYSTEM REPLACED; I HAD TO HAVE THE KEYPAD ON THE DOOR PANEL REPLACED; I HAVE HAD TO HAVE THE POWER STEERING EPAS REPLACED (MOST RECENT). MOST HAPPENED WHILE THE VEHICLE WAS STATIONARY THANK GOODNESS. THE NAVIGATION SYSTEM DID GO OUT WHILE DRIVING.
Aug 08, 2017
ELECTRICAL SYSTEM,ELECTRONIC STABILITY CONTROL (ESC),FUEL/PROPULSION SYSTEM
1 complaint
I AM AN OWNER OF A 2016 FORD EXPLORER THAT WAS PURCHASED BRAND NEW AT A DEALERSHIP HERE IN AZ LAST YEAR IN JANUARY. IMMEDIATELY AFTER PURCHASE, I STARTED NOTICING FUEL LEAKAGE FROM THE VEHICLE AND VEHICLE USING A LOT OF GAS EVERYDAY. I TOOK MY TRUCK BACK TO THE DEALERSHIP AND WAS TOLD EVERYTHING IS OK. AS TIME WENT ON, I NOTICED THAT EVERY TIME I ACCELERATED ON THE GAS, THE TRUCK SLOWED DOWN. TOOK TRUCK TO DEALERSHIP AND WAS TOLD ONCE AGAIN NOTHING IS WRONG. A COUPLE OF MONTHS AGO, THE BATTERY DIED. I HAVE THE TRUCK TOOWED TO THE DEALERSHIP AND THEY REPLACED THE BATTERY. TWO WEEKS LATER, THE BATTERY DIES AGAIN. I HAD IT TOWED TO THE DEALERSHIP AGAIN. THEY REPLACED THE BATTERY AGAIN AND NOTICED A RECALL ON THE TRUCK. A WEEK LATER I'M DRIVING MY KIDS TO SCHOOL WHEN THE DASHBOARD GOES BLACK AND THEN LIGHTS UP AGAIN. ALL OF A SUDDEN IT HAPPENS AGAIN, THE DASHBOARD GOES BLACK AND THE SPEED STARTS DECELERATING. I HURRY UP AND GET TO THE SAFETY SIDE OF THE HIGHWAY. I CUT THE TRUCK COMPLETELY OFF, WAITED A FEW MINUTES AND IT STARTED RIGHT BACK UP. I TOOK THE TRUCK TO THE DEALERSHIP. ONCE AGAIN, I'M TOLD THAT NOTHING IS WRONG WITH THE VEHICLE. YESTERDAY THE TRUCK DASHBOARD STARTS GOING ON AND OFF. THEN THE TRUCK COMPLETELY DIES. I CALLED ROADSIDE ASSISTANCE AND HAD THE TRUCK TOWED TO THE DEALERSHIP. I WAITED FOR OVER 5 HOURS AT THE DEALERSHIP BEFORE THEY TOLD ME WHAT "MIGHT" BE THE PROBLEM. I WAS TOLD THERE MIGHT BE AN ELECTRICAL SHORTAGE BETWEEN THE MONITOR, RADIO, ODOMETER, AND CLIMATE CONTROLS THAT IS CAUSING THE VEHICLE TO SHUT DOWN. THE DEALERSHIP DOESN'T HAVE PARTS TO FIX IT BUT CAN ORDER THEM AND IT MIGHT TAKE A FEW WEEKS TO GET THEM. AS OF NOW I HAVE NO AIR CONDITIONER AND MY RADIO ISN'T WORKING. I HAVE SPOKEN WITH SEVERAL CUSTOMER SERVICE MANAGERS ABOUT THE VEHICLE AND WAS TOLD THERE ISN'T ANYTHING THAT CAN BE DONE EXCEPT WAIT FOR FORD TO FIX IT.
Jul 06, 2017
ELECTRICAL SYSTEM,STRUCTURE,SEATS
1 complaint
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE TRAVELING 25 MPH, THE TAILGATE INADVERTENTLY OPENED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE ISSUE COULD NOT BE DUPLICATED. THE CONTACT STATED THAT THE FAILURE HAD NOT RECURRED WHILE DRIVING, BUT WHILE THE VEHICLE WAS PARKED. THE CONTACT CLOSED THE TAILGATE, BUT IT WOULD RE-OPEN. WHILE THE TAILGATE WAS OPEN, IT CLOSED UNEXPECTEDLY AND INJURED THE CONTACT'S HEAD. MEDICAL ATTENTION WAS NOT REQUIRED. THE CONTACT STATED THAT HE WAS AWARE OF THE SENSOR FOR THE TAILGATE. ALSO, WHEN THE VEHICLE WAS STARTED, THE DRIVER'S SEAT MOVED FORWARD AND INJURED THE CONTACT'S RIGHT KNEE. MEDICAL ATTENTION WAS REQUIRED. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE, BUT THE VEHICLE MODULE WAS REPROGRAMMED. THE CONTACT ALSO STATED THAT THE VEHICLE HAD SEVERAL ELECTRICAL ISSUES BECAUSE THE INSTRUMENT PANEL DISPLAY WOULD NOT OPERATE OR OPERATED INCORRECTLY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS APPROXIMATELY 500.
Feb 22, 2017
FUEL SYSTEM, GASOLINE,POWER TRAIN
1 complaint
WHEN DRIVING AT 65MPH ON INTERSTATE 287 THE CAR DID A SLIGHT JOLT AND THEN LOST ALL POWER. THE ENGINE REMAINED RUNNING, POWER STEERING AND BRAKES STILL WORKED, BUT THERE WAS NO ACCELERATION. WRENCH LIGHT AND CHECK ENGINE LIGHTS CAME ON. LUCKILY I WAS NEAR AN EXIT SO I COASTED TO A HALT OFF THE INTERSTATE. I RESTARTED THE CAR, IT DROVE AT NO MORE THAN 5MPH TO A SAFER SPOT. AFTER SOMETIME WAITING FOR A TOW TRUCK I RESTARTED THE CAR, IT WORKED THIS TIME BUT WITH A CHECK ENGINE LIGHT. I DROVE SLOWLY AND ON COUNTY ROADS, BACK HOME. NOW IN DEALER TO BE FIXED. I HAVE READ MULTIPLE EXAMPLES OF THIS PROBLEM ON THIS WEBSITE AND GENERALLY. THERE IS A CLEARLY A MAJOR SAFETY ISSUE WITH THESE ENGINES AND IT NEEDS ADDRESSING AT A WIDER LEVEL THAN SIMPLY EACH CONSUMER. *TR
Oct 31, 2016
FUEL SYSTEM, GASOLINE,VEHICLE SPEED CONTROL
1 complaint
WHILE DRIVING WITH CHILDREN PRESENT THE CAR SUDDENLY LOST POWER AND MY WIFE COULD NOT ACCELERATE. SHE HAD TO DRIFT OVER TO THE SIDE OF THE ROAD. THE "WRENCH" LIGHT AND CHECK ENGINE LIGHT CAME ON THE DASH. AFTER STOPPING THE CAR AND RESTARTING SHE WAS ABLE TO GET HOME BUT THE CAR HAS ALMOST NO ACCELERATION AND KEPT SHUDDERING. FORTUNATELY THE ROADS WERE QUITE AND THERE WAS NO DAMAGE OR INJURY. IF SHE WAS ON A BUSY ROAD OR HIGHWAY IT WOULD HAVE BEEN VERY DANGEROUS. CAR HAS AROUND 7000 MILES ON THE CLOCK. *TR
Oct 24, 2016
POWER TRAIN,ELECTRONIC STABILITY CONTROL (ESC)
1 complaint
2016 FORD EXPLORER WITH APPROXIMATELY 8400 MILES. WAS TRAVELING SOUTHBOUND ON US HWY 1 AT APPROXIMATELY 50MPH WHEN VEHICLE SUDDENLY STOPS ACCELERATING AND WRENCH LIGHT COMES ON. CAR WILL ONLY COAST AT LESS THAN 5MPH. WAS ABLE TO PULL INTO A PARKING LOT WITHOUT BEING INVOLVED IN AN ACCIDENT. VEHICLE WAS ON AND SHAKING BUT WOULD NOT ALLOW ME TO ACCELERATE. VEHICLE HAD TO BE TOWED TO FORD DEALERSHIP. FORD MECHANIC STATED IT WAS THE ELECTRONIC THROTTLE BOTTLE AND THEY HAVE ALREADY HAD A FEW OF THEM COME IN TO BE REPLACED. ETB HAS BEEN REPLACED BUT VEHICLE STILL LAGS WHEN ACCELERATING. WENT ON CARSCOMPLAINTS.COM AND 38 COMPLAINTS HAVE ALREADY BEEN FILED FOR THE SAME ISSUE.
Oct 04, 2016
POWER TRAIN,ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM
1 complaint
2016 FORD EXPLORER [XXX] LOST POWER AND WOULD NOT MOVE IN MIDDLE OF BUSY HIGHWAY. VEHICLE WAS NOTED TO HAVE A SPUTTERING SOUND AND APPEARED TO BE FIRING ON ONLY A FEW CYLINDERS. TURNED VEHICLE ENGINE OFF AND RESTARTED NO HELP VEHICLE WOULD NOT MOVE WITH ACCELERATOR PEDAL IN FULL OPEN (FLOORED) POSITION. AFTER OPENING HOOD AND DISCONNECTING NEG TERMINAL OF BATTERY VEHICLE OPERATED FINE FOR APPROX 10 MILES AND THEN SAME OCCURENCE. AGAIN FAULT CLEARED AND RAN FINE TO NEAREST FORD DEALER. INITIAL DIAGNOSIS BY DEALER WAS CODES P2111 AND P2112. DEALER STATED FOUND RECALL 16B32 FOLLOWED INSTRUCTIONS AND REPROGRAMMED PCM AND CLEAR CODES. CUSTOMER DEPARTED DEALERSHIP SERVICE BAY AND REPEAT ABOVE MENTIONED MALFUNCTION BEFORE OFF THE DEALER LOT. RETURNED TO SERVICE BAY AND DEALER STATED THAT THROTTLE BODY WAS CHANGED. VEHICLE APPEARS TO BE OPERATING NORMAL AT THIS TIME. THIS IS A SAFETY ISSUE THAT SHOULD BE INVESTIGATED. MY WIFE WAS DRIVING THE VEHICLE WHEN THIS FIRST OCCURRED IN BUSY MOUNTAIN HIGHWAY HERE IN SOUTHERN WV AND WAS NEARLY HIT BY NUMEROUS VEHICLES BEFORE VEHICLE COULD BE DRIFTED BACKWARDS DOWN THE MOUNTAIN WHERE IN ORDER TO GET VEHICLE OFF OF HIGHWAY. SERVICE ADVISER INDICATED THAT HE HAD SEEN SEVERAL SIMILAR PROBLEMS WITH THE 3.5 LITER ENGINE IN FORD EXPLORERS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Sep 29, 2016
POWER TRAIN,VEHICLE SPEED CONTROL,FUEL/PROPULSION SYSTEM
1 complaint
I WAS DRIVING ON 675 IN DAYTON OHIO AT 65-70 MILES AN HOUR WHEN MY FORD EXPLORER XLT LOST ALL ACCELERATION AND I WAS FORCED TO COAST TO A STOP ON THE LEFT SHOULDER OF THE HIGHWAY. I WAS ABLE TO TURN THE CAR OFF AND RESTART IT, AND DRIVE IT HOME WITHOUT INCIDENT. I HAD IT TOWED TO A FORD DEALER AND HOPEFULLY WILL HAVE AN ANSWER TOMORROW. THIS VEHICLE IS A 2016 XLT WITH JUST OVER 8,000 MILES. I NO LONGER TRUST THIS VEHICLE AND WILL BE RESEARCHING MORE RELIABLE VEHICLES.
Sep 29, 2016
ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM
1 complaint
THE VEHICLE KEEPS LOSING FUEL AND FUEL HAS TO BE REPLACED EVERY OTHER DAY. TOOK VEHICLE INTO FORD DEALERSHIP TO BE CHECKED OUT AND WAS TOLD VEHICLE IS SAFE TO DRIVE. GAS CAN BE SMELT AND VISIBLY GUSHES AFTER FUELING IN STATIONARY POSITION. WHEN VEHICLE IS IN DRIVE MOTION, GAS LEAKS SLOWLY. ALSO, WHILE DRIVING THE VEHICLE JERKS AND WILL SLOW DOWN ACCELERATION.
Sep 23, 2016
STEERING,POWER TRAIN,VEHICLE SPEED CONTROL
1 complaint
WHILE DRIVING BELOW 30 MPH ATTEMPTED TO ACCELERATE AND FELT A JOLT,ENGINE CUT OFF,"WRENCH" LIGHT AND AIR BAG LIGHT CAME ON (LAST ONE PROBABLY WHEN THE ENGINE SHUT OFF).HAD TO COAST TO THE SIDE,RE-STARTED ENGINE AND IT STARTED SHAKING,RPMS KEPT GOING UP AND DOWN BETWEEN 1-2000.TURNED OFF AND WAITED A FEW MINUTES.STARTED ENGINE AGAIN AND IT WAS RUNNING NORMAL EXCEPT CHECK ENGINE WAS ON.WENT TO LOCAL FORD DEALER (WE WERE ON VACATION) WHO COULDN'T TAKE US IN FOR AT LEAST 6 HRS AND WANTED US TO PAY FOR DIAGNOSTIC (NEW CAR,JUST HAD FIRST OIL CHANGE).WENT TO AUTO ZONE AND THEY READ CODE P2112 -THROTTLE BODY FAILURE AND ARMED WITH THAT SCHEDULED SERVICE AT MY LOCAL DEALER.ON THE WAY BACK ISSUE REPEATED ITSELF TWO MORE TIMES.ALL ON LOWER SPEEDS (CITY DRIVING).CURRENT MILES 6200.
Aug 26, 2016
ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL
1 complaint
2016 FORD EXPLORER. CONSUMER WRITES IN REGARDS TO VEHICLE COMPLETE LOSS OF POWER, AIRBAG, CHECK ENGINE AND POWERTRAIN WARNING LIGHTS ILLUMINATED AT VARIOUS TIMES AND ACCELERATOR MALFUNCTION. *SMD THE CONSUMER STATED WHILE DRIVING ON A MAIN ROAD, HE HEARD A LOUD THUD ACCOMPANIED BY AN IMMEDIATE AND COMPLETE LOSS OF POWER. THE ENGINE WAS STILL RUNNING, BUT THE VEHICLE QUICKLY LOST SPEED AND THE ACCELERATOR WAS NOT FUNCTIONING. IT SEEMED AS THOUGH THE ENGINE WAS IDLING. THE CONSUMER WAS ABLE TO MANEUVER THE VEHICLE SAFELY OUT OF TRAFFIC AND HAD THE VEHICLE TOWED TO THE DEALER. THE DEALER INFORMED THE CONSUMER, THE THROTTLE BODY NEEDED TO BE REPLACED. ALSO, THERE WAS A RECURRING ELECTRICAL ISSUE THAT HE EXPERIENCED IN JANUARY 2016 WITH THE FIRST MONTH OF DELIVERY. THE VEHICLE WAS TOWED TO THE DEALER FOR SERVICE ON TWO SEPARATE OCCASIONS DUE TO DEAD BATTERIES. *JB
Jul 28, 2016
WHEELS,ENGINE
1 complaint
WHILE MOVING AT HIGH SPEED IN RUSH-HOUR TRAFFIC IN THE FAST LANE ON HWY 680 S IN DUBLIN, CA THE ENGINE JUST SHUT DOWN. THIS IS DANGEROUS. THE CAR WAS TOWED TO FORD FOR REPAIR - THEY STATE IT WAS A "THROTTLE BODY ASSEMBLY" PROBLEM - APPARENTLY A WELL-KNOW PROBLEM. THIS HAPPENED WITH LESS THAN 6,000 MILES. ALSO, ALL 4 ORIGINAL EQUIPMENT TIRES BLEW-OUT WITH LESS THAN 6,000 MILES - ONLY ONE HAD A ROAD-HAZARD - ALL HAD SIDEWALL FAILURES. FORD REPAIRED THE THROTTLE-BODY ASSEMBLY BUT NOT THE TIRES. TO KEEP US HAPPY, THEY OFFERED US AN "EXTENDED WARRANTY" - THIS WAS NEVER PROVIDED - INDEED, DESPITE REPEATED E-MAILS TO 2 FORD REPRESENTATIVES OVER A 3-MONTH TIME-PERIOD, I NO LONGER RECEIVE ANY RESPONSE FROM THEM WHATSOEVER. THEREFORE, IT WOULD SEEM THAT NOT ONLY ARE THEY PROVIDING A DANGEROUS PRODUCT, THEY ARE ALSO DECEPTIVE IN THEIR HANDLING OF CUSTOMERS.
Jul 20, 2016
STEERING,POWER TRAIN,VEHICLE SPEED CONTROL,UNKNOWN OR OTHER,SERVICE BRAKES,ENGINE
1 complaint
HUSBAND WAS DRIVING THE VEHICLE WAS ABOUT TO ACCELERATE TO GET UP A HILL ON A CITY STREET AND ENGINE SOUNDED LIKE TRANSMISSION OR OTHER MAJOR PART JUST "DROPPED". STEERING WHEEL FROZE, CAR IDLED VIOLENTLY, COULD NOT MOVE VEHICLE, STARTED TO ROLL BACKWARDS UNTIL EMERGENCY BRAKE WAS APPLIED.ACCELERATION WENT TO LITERALLY ZERO,SUV WOULD NOT MOVE. ORANGE WRENCH LIGHT CAME ON, STATED TO SEE MANUAL.PLACED CAR IN PARK SHUT OFF ENGINE AND WAITED AND STARTED AT BACK UP AGAIN. SCARRY STUFF, 2 CHILDREN 2 AND YOUNGER IN VEHICLE. WON'T LET ME INPUT ON NEXT PAGE, APPROXIMATELY 25-30 MILES AN HOUR, SUV HAS 5,500 MILES ON IT
Jul 17, 2016
STEERING,VEHICLE SPEED CONTROL,ENGINE
1 complaint
I WAS DRIVING MY 2016 FORD EXPLORER ON A BUSY STREET WHEN THE ENGINE LIGHT AND THE ORANGE WRENCH LIGHT CAME ON. THE CAR STALLED AND WOULD NOT ACCELERATE.IT LOST ALL POWER. I AM TERRIFIED OF DRIVING IT NOW. IT WOULD NOT MOVE FASTER THAN 5 MILES PER HOUR. THE CAR HAS 6,000 MILES ON IT.
Jul 11, 2016
ELECTRICAL SYSTEM,STRUCTURE,FUEL/PROPULSION SYSTEM
1 complaint
HI I NEED HELP WE ARE HAVING ISSUE WITH OUR 2016 FORD EXPLORER SPORT WE ONLY HAVE IT FOR 3 MONTHS 2K MILEAGE, WE NOTICED THE HOOD VIBRATE AT 65MPH OR OVER ON FREEWAY, I BROUGHT IT TO MY NEAREST FORD DEALER, "FORD SERRAMONTE" ON 05/16/16 THE SERVICE MANAGER NAME HENRY SAID THEY ARE AWARE OF IT BUT COULDN'T DO ANYTHING & THEY ARE WAITING FOR FORD TO FIND THE SOLUTION TO FIX IT, BUT THEY DIDN'T EVEN CHECK THE HOOD. I CONTACTED FORD CUSTOMER CARE TEAM ON 05/18/16 & THEY OPEN A CASE, CASE NUMBER: CAS-9514452-P1Y5C2 TARA MELVIN COSTUMER CARE MANGER HANDLING THE CASE. WE ARE PROSTRATED BECAUSE IT'S BRAND NEW CAR & ALREADY HAS A LOT OF PROBLEMS, IT WAS DISTRACTIVE DRIVING THE VEHICLE SO I'M SCARED SPECIALLY I'M ALWAYS WITH MY 1YR & 4YRS OLD SON, THEY JUST TOLD ME TO WAIT & IT'S BEEN MORE THAN A MONTH NOW & STILL HAVEN'T FIX THE PROBLEM. WE BOUGHT THIS SUV THINKING IT'S A RELIABLE & SAFETY CAR FOR OUR FAMILY BUT THERE'S TO MUCH ISSUES, -BATTERY DIED, I CALLED THE ROADSIDE ASSISTANCE, THE DEALER SAID IT MIGHT BE THE BACK UP CAMERA THAT CONSUMING THE POWER FROM THE BATTERY WHEN THE VEHICLE IS NOT RUNNING, NOW THE CAMERA IS BACKORDER ACCORDING TO THE DEALER. WE'RE SCARED IT WILL HAPPEN AGAIN IF WE'RE ON A TRIP. -LOW FUEL ECONOMY, I'M ONLY GETTING 12.6 AVG MPG. EPA COMBINED 18MPG, 16 CITY & 22 HIGHWAY I BEEN DOING A RESEARCH REGARDING ABOUT THE HOOD VIBRATION PROBLEM & FINDING THIS PROBLEM IS BEEN GOING AROUND SINCE 2013 & THERE'S A LOT OF VEHICLE OWNER THAT HAVE THE SAME PROBLEM, MY WIFE BROTHER IN-LAW HAS THE SAME PROBLEM VIBRATING HOOD 2016 FORD EXPLORER LIMITED. I ATTACHED SOME OF THE LINK REGARDING THE SAME ISSUE. LINK FORUM: HTTP://WWW.EXPLORERFORUM.COM/FORUMS/INDEX.PHP?THREADS/MY-EXPLORER-HOOD-VIBRATES-AND-HUMMING-NOISES.385592/ HTTP://WWW.EXPLORERFORUM.COM/FORUMS/INDEX.PHP?THREADS/ENGINE-NOISE-HOOD-VIBRATES.444789/#POST-3532126 THANKS!
Jun 10, 2016
AIR BAGS,VEHICLE SPEED CONTROL,ENGINE
1 complaint
A WEEK AGO THE VEHICLE SHOWED 45 MILES TILL EMPTY. BACKED OUT OF THE DRIVE WAY TO GET GAS AND THE CAR LOST ALL POWER. DASH SHOWED ENGINE LIGHT AND AIR BAG. FILLED UP WITH GAS AND THE LIGHTS WENT AWAY. TODAY, GOING DOWN THE HIGHWAY I LOST ALL POWER. TALK ABOUT ACCIDENT WAITING TO HAPPEN! LUCKILY I WAS ABLE TO CRUISE TO A EXIT AND INTO A PARKING LOT. HAD TO CALL FORD TOWING TO COME AND GET ME. THIS IS A 2016 FORD EXPLORER. ONLY 7000 MILES. BRAND NEW VEHICLE SHOULD NOT HAVE THIS TYPE OF PROBLEM. THEN THE SENSORS AROUND THE CAR GO OFF WHEN THERE IS NOTHING AROUND. I KNOW I AM NOT THE ONLY PERSON WITH THIS LOST OF POWER ISSUE. I BELIEVE THAT THE ONLY WAY TO ACTUALLY GET SOME ASSISTANCE WITH THIS PROBLEM IS AFTER SOMEONE GETS HURT AND SUES FORD. ANOTHER PROBLEM IS THERE IS A KNOCKING SOUND AS SOON AS THE CAR IS TURNED ON AND DRIVEN. YOU FEEL AND THE STEER WHEEL KNOCK ALONG WITH THE SOUND.
Apr 11, 2016
SEATS,ENGINE
1 complaint
HAD MY FORD EXPLORER 6-MO'S AND WAS DRIVING WITH FAMILY APPROX 45-MPH IN TRAFFIC ON A MAIN STREET WHEN THE GAS PADEL JUST STOP WORKING HAD TO TRY TO GET TO SIDE OF ROAD, VERY DANGEROUS !! . CAR WAS AT FORD DEALER GETTING FIXED FROM 3/14- 3/25 , IT NEEDED A NEW THROTTLE BODY AIR INTAKE, (AT4Z*9E926*B ) AND MOTOR ASY.
Mar 31, 2016
VEHICLE SPEED CONTROL,EQUIPMENT ADAPTIVE/MOBILITY,SERVICE BRAKES
1 complaint
SEPT 31ST - WITH 358 MILES AND LESS THAN OWNED FOR 24 HOURS ALL ADAPTIVE EQUIPMENT FAILED, FLASHING ABS FAILURE LOSS OF SPEED CONTROL. OCT 1ST CAR TAKEN TO JCLEWIS FORD IN SAVANAH,GA, WAS CALLED BY THE DEALER APPROXIMATELY 3 HOURS LATER AND WAS TOLD TO PICK THE CAR AND THE ONLY PROBLEM WAS TO REALIGN AND RESET COMPUTER SOFTWARE. I TOOK THE CAR AND DROVE 39 MILES AND WE SUSTAINED A TOTAL REPEAT OF THE PROBLEMS. AT THIS POINT THE DEALERSHIP SAID THEY HAD NO IDEA AT POINT WHAT WAS WRONG OR THE CAUSE OF THE PROBLEM, APPROXIMATELY FIVE DAYS LATER I WAS TOLD THE CAUSE WAS THE FAILURE OF THE REAR ABS WHEEL SENSOR WHICH THEY TOLD ME WAS REPLACED AND ALSO THAT THEY HAD DRIVEN THE CAR FOR FEW DAYS AND IT WAS NOW OPERATIONAL. I DID PICK UP THE CAR AND AGAIN WITHIN A FEW MILES WE SUSTAINED THE SAME FAILURE WITH AN ADDED FEATURE I BACKED OUT OF MY PARKING SPACE AND FOUND THAT I HAD LOST ANY ABILITY TO MOVE FORWARD AND THERE WAS A SEVERE GRINDING NOISE EMANATING FROM TRANSMISSION, DROVE THE BACK TO DEALER SHIP FOR THE FOURTH TIME AND WAS TOLD THAT EVEN THOUGH I WAS TOLD THAT THE FORD DEALER MECHANIC DID NOT REPLACE ANY PARTS AS I WAS TOLD. AS OF TODAY SEPT 18TH THE CAR IS STILL WITH THE DEALER AND WAS TOLD THAT IN FACT REPLACED THE LEFT ABS WHEEL SENSOR BUT THEY SAID THAT IN FACT WAS NOT THE PROBLEM AND THAT IT STILL EXISTED. I WAS TOLD THAT THEY WERE THINK IT IS BEING CAUSED BY SOME TYPE OF SHORT IN A WIRE HARNESS BUT THEY STILL ARE AWAITING PARTS. I HAVE REQUESTED A MEETING WITH A FORD REPRESENTATIVE BUT I WAS TOLD BY THE SERVICE MANAGER THAT HE COULD NOT ARRANGE A MEETING. I WAS TOLD BY A FORD REPRESENTATIVE I BELIEVE DETROIT THAT I SHOULD LOOK AT THE BACK OF THE OWNERS MANUAL FOR ADVICE ON THE LEMON LAW.
Sep 18, 2015
Frequently Asked Questions
How many problems does the 2016 FORD Explorer have?
The 2016 FORD Explorer currently has 2332 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.
What are the most common problems with 2016 FORD Explorer?
The most common problems reported for the 2016 FORD Explorer are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.
Where does this 2016 FORD Explorer problem data come from?
All problem and complaint data for the 2016 FORD Explorer comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.
Other Years - FORD Explorer
2025 Problems
2024 Problems
2023 Problems
2022 Problems
2021 Problems
2020 Problems
2019 Problems
2018 Problems
2017 Problems
2015 Problems
2014 Problems
2013 Problems
2012 Problems
2011 Problems
2010 Problems
2009 Problems
2008 Problems
2007 Problems
2006 Problems
2005 Problems
2004 Problems
2003 Problems
2002 Problems
2001 Problems
2000 Problems
1999 Problems
1998 Problems
1997 Problems
1996 Problems
1995 Problems
1994 Problems
1993 Problems
1992 Problems
1991 Problems
1990 Problems
Other FORD Models
'34
1500 Foldaway
A8513
A9513
A9522
Aerostar
Affordable Aluminum
Affordable Trailers
Aspire
AT8513
AT9513
AT9522
Similar Brands
ST
3,555 models
RS
3,484 models
NC
2,822 models
ND
2,385 models
Z
1,951 models
MOTO
1,583 models
NU
1,189 models
RC
1,122 models