How many problems does the 2017 FORD Explorer have?

The 2017 FORD Explorer currently has 1536 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2017 FORD Explorer?

The most common problems reported for the 2017 FORD Explorer are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2017 FORD Explorer problem data come from?

All problem and complaint data for the 2017 FORD Explorer comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.

2017 FORD Explorer Problems

STRUCTURE

511 complaints

The parts subject to the 3 recalls fail and fall off the vehicle under highway driving conditions. They have not made any effort to redesign the parts so they don't fail and they have made no effort to even replace the failed parts with the existing parts. The last time the recall was issued, I was advised by our dealer to use duct tape.

Dec 16, 2025

I was driving down the road and my roof driver's side roof rail flew off. The previous owner had the recall addressed in 2023. The previous dealership who fixed the vehicle glued down the rails instead of installing new screws. There is dried glue now exposed where the roof rack use to be. When contacting Ford they claim there is no resolution but for me to fix my own roof rack though it was recalled for this issue. Thankfully no one was behind me when it flew off but it could have hit someone else or damaged my window that it hit when it flew off. The passenger side is also loose and showing the dried glue as well. Ford states that since the warranty period has expired there is nothing they can do. I cannot find the roof rail on the road to put it back and have been told it is $400+ just for the part. This is a safety hazard that was supposed to be fixed and there is no telling when the next one will come off as that is loosening as well.

Dec 15, 2025

The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); and later became aware that the VIN was included in NHTSA Campaign Number: 21V316000 (Structure); however, the parts to do the recall repairs were not yet available. The contact stated that the trims around the windshield, including the driver's side and passenger's side windshield exterior A-pillar trims, were disintegrating and had partially detached. The contact was initially informed by a car wash employee about the trim failures and advised the contact that the vehicle was unsafe to drive through the car wash. The local dealer was contacted and informed the contact that the VIN was not under recall. Additionally, the dealer informed the contact that there was no early availability to perform the inspection on the vehicle. Additionally, the contact stated that the roof rail cover was partially raised. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the failures. The failure mileage was approximately 80,000.

Dec 15, 2025

The contact owns a 2017 Ford Explorer. The contact stated that while entering the vehicle, the A-pillar trim on both sides of the windshield was not functioning as designed. The contact also noticed water leaking from the windshield during inclement weather. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure); however, the parts for the recall repairs were not yet available. The local dealer was contacted, and a dealer representative visited the residence to inspect the vehicle. The dealer determined that the A-pillar trim had failed and needed to be replaced. The vehicle was not repaired, and the dealer confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the failure. The failure mileage was not available.

Dec 10, 2025

The contact owns a 2017 Ford Explorer. The contact stated that while driving approximately 65 MPH, the driver's side A-pillar trim was blown off the vehicle by the slipstream. The contact called a local dealer and was informed that parts were not yet available. The contact had received notification of NHTSA Campaign Number: 24V031000 (Structure) in February 2025. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 54,000.

Dec 09, 2025

+ 506 more complaints for this component

UNKNOWN OR OTHER

247 complaints

Safety Recall Notice 24S02/NHTSA Recall 24V031 - Exterior A-pillar applique trim clip attachments may not be properly engaged due to improper assembly. Two-step solution is required: Ford dealer has to check to see if the clips are properly engaged or not, then, if not, must order the correct parts from Ford. I have been trying to correct this issue for over two years, but dealer says the parts are still on back order from Ford and repairs cannot be made.

Dec 13, 2025

Since Ford issued the first recall notice for Recall 24S02, I have been contacting my local Ford dealerships every few months to check whether the replacement parts were available. Each time, I am told the parts are still not in stock. As of today, multiple pieces of my vehicle have flown off while I was driving. This has become a serious safety hazard. Most recently, while driving on the freeway, a part detached from my car and the vehicles behind me had to swerve to avoid hitting it. I am increasingly concerned for my safety and the safety of others on the road. At this point, my vehicle does not feel safe to drive, but I have no alternative transportation. This appears to be a straightforward part for Ford to manufacture and replace, yet the delay has been unreasonable. Something needs to be done— I cannot continue driving a vehicle where pieces are literally coming off while in motion.

Dec 01, 2025

The windshield outer trim pillar molding has flown off my vehicle twice while driving on the highway. This last time it almost hit someone on a motorcycle. What is Ford going to do to fix this?

Oct 20, 2025

UNKNOWN. The rubber seal for the windshield wiper cowl is completely deteriorating. This is a known common problem as the ford dealership parts department stated. With this rubber seal deteriorating its possible for wind to get under the cowling and blow it off while driving down the road causing a hazard for surrounding drivers.

Sep 28, 2025

A buzzing started coming from my front dash. My mechanic pointed out the molding/trim on the windshield is basically disintegrating because of cheap quality materials.

Sep 21, 2025

+ 242 more complaints for this component

ENGINE

127 complaints

Complete failure of the water pump at 58000 miles.

Nov 17, 2025

The contact owns a 2017 Ford Explorer. The contact stated that upon taking the vehicle for an annual smog check, the check engine warning light was illuminated on the instrument panel. The vehicle was taken to the dealer, where a diagnostic test was performed. The diagnostic showed that the VVT (Variable Valve Timing) connected to the timing phasers had fractured and needed to be replaced. The contact was provided with an estimate for the repair. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 73,838.

Nov 14, 2025

There was cam phaser situation that i was never informed of when this car was purchased. I just hit 80 k and i am now having issues. It appears there is a lawsuit for this. What is ford doing to fix.

Jun 22, 2025

The car makes a ticking/rattle sound on cold startup. Preliminary diagnosis is the cam phasers. This is a 2017 Ford explorer with 77,000. It is the same 3.5L V6 ecoboost (GTDI) engine that was in Ford Customer Satisfaction program: 21N03. The issue mirrors tgat in the program document, but the Explorer is not covered by the program.

Jun 12, 2025

I brought my vehicle from a used certified dealer at the time of test drive I asked why such a rough transition when going from gear to gear and I was told it was the ECOBoost engine packed with power. Fast forward after multiple repairs and recalls on this vehicle I’ve made it to my breaking point when my SUV shut down as I was turning onto a busy street coming from my son’s school. The engine literally cut off almost causing a head on collision. This idle function is extremely dangerous. I had multiple belts repaired and many things checked after my car overheated and couldn’t find the culprit. One mechanic explained my fan wasn’t working to assist in cooling off the engine and the vents/grill in front of car was shut causing the engine to over heat. After opening the vents and connecting the car to diagnostic machine there were no codes to fix. Over the next month my suv would become significantly worse rattling when I stop at a red light almost drifting into a car in front of me. No longer overheating but now feeling the car physically shifting gears as if I drive a stick shift and I have an automatic transmission. After doing careful research I learned was some recalls on the fan and eco boost engine explaining the same issues that I’am currently having. Don’t mention fixing the recalls because all the certified dealers are 2-3 weeks behind on fixing and diagnosing these same vehicles. They won’t loan you a car while being repaired which is another cost associated with this vehicle. Please look into this ecoboost engine and overheating issues. Also I was told my engine would go soon do the oxygen intake not exchanging enough oxygen causing oil to push into spark plugs and other parts of the engine it doesn’t belong. This SUV is a complete lemon and should be recalled right away before someone dies from this awful feature. Just last week I saw someone on the interstate with my same vehicle stopping mid traffic. This is dangerous!!!

May 23, 2025

+ 122 more complaints for this component

POWER TRAIN

70 complaints

When i start the vehicle, and press the bbrake and shift into drive, the vehicle shakes and jolts. When I remove my foot from the break to push the gas petle, there is a hesitation/stall out unless I push it quickly. The shaking and jolting occurs when the vehicle is in drive and reverse, but stops when the car is in neutral or park. In order to operate the vehicle in traffice, I have to put it in neutral at stop signs and traffic lights, or it will shake, jolt and stall out. This can not be safe!

Oct 27, 2025

On [XXX] as I stopped at the stoplight my car started to shake/shudder when it was green I started to drive and it stopped. Then when I stopped again while in drive I experienced the same thing. Contacted the dealership where I've been servicing my car since I bought it. I was hoping they could take in that day but they were booked. Next available was July 17, 2025. They did a diagnostic on my car and said it was the motor mounts. Had to order the parts and will call when parts are in. Parts came in and it was scheduled. Took them all day and even after shop closed to put the motor mounts on. When I picked it up I was told it was still shaking/shuddering but not as bad. Told me to take it home and see. Called them back to bring it back in due to shaking/shuddering, they did another diagnostic this time its my torque converter. Total with parts and labor $2819.19 plus tax. I started doing some research and found this was a common problem for my type of car. It's on Fords customer satisfaction 20N07. My car fall meets all that is required. Contacted Ford multiple times and was turned down saying there was no recall for mines even though it was manufactured at that specific plant. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Aug 09, 2025

The contact owns a 2017 Ford Explorer. The contact stated that while driving at an undisclosed speed and approaching a stop, the vehicle briefly jump and jolted. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 50,000.

Jun 09, 2025

The transmission has totally failed at under 69,000 miles while my wife was driving down a 45 MPH road. The vehicle intermittently lost power and she was nearly rear-ended with my child in the car. All warning lamps came on and the engine totally lost power. 2 shops have looked at the car and stated that the transmission failed completely. There were no warning lamps prior to this occurring.

Jun 05, 2025

The contact owns a 2017 Ford Explorer. The contact stated while driving 65 MPH, the vehicle made an abnormal whining sound. The message to "See Owner’s Manual" was displayed with a wrench symbol. The contact stated that while depressing the accelerator pedal, the vehicle failed to accelerate, nearly causing a crash. The contact was able to pull over to the side of the road. The contact stated that upon shifting from park(P) to drive(D), the vehicle failed to respond. The vehicle was towed to Matt's Repairs, where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and informed the contact that the vehicle could not be covered because the vehicle was out of warranty. The failure mileage was approximately 97,000.

May 02, 2025

+ 65 more complaints for this component

ENGINE AND ENGINE COOLING

57 complaints

The contact owns a 2017 Ford Explorer. The contact stated that while driving approximately 55 MPH, the message “Engine Overheating” was displayed. The contact pulled over to the side of the road and allowed the engine to cool down. After restarting the vehicle, there was an abnormal clicking sound coming from the engine compartment. The contact then noticed a fluid leak underneath the front of the vehicle. The vehicle was towed to the mechanic and the mechanic diagnosed the vehicle and determined that the water pump was leaking, causing the engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact discovered that the failure was a known issue; however, the VIN was not under recall related to the failure. The dealer was contacted and confirmed that there was no recall on the VIN related to the failure. The manufacturer was not informed of the failure. The failure mileage was approximately 190,000.

Aug 22, 2025

The contact owns a 2017 Ford Explorer. The contact stated that while driving at various speeds, the vehicle was driving roughly, with white exhaust smoke coming from the vehicle. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the local dealer, who diagnosed that there was coolant intrusion in the engine. The contact was informed that the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 110,000.

Aug 07, 2025

The contact owns a 2017 Ford Explorer. The contact stated while driving at an undisclosed speed, there was an unknown warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with a failed coolant pump. The contact was informed that the coolant pump needed to be replaced. The vehicle was not repaired. The contact was advised to tow the vehicle to the dealer. The dealer was made aware of the failure. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. In addition, the contact was informed that NHTSA would add the VIN to an unknown recall with similar failure. The failure mileage was approximately 93,000.

Aug 06, 2025

The contact owns a 2017 Ford Explorer. The contact stated while driving at an undisclosed speed, the vehicle hesitated while depressing the accelerator pedal without warning. The vehicle was taken to a dealer where the mechanic discovered an oil leak coming from the engine. The contact was informed that the vehicle was not under warranty and the contact was referred to the manufacturer. The manufacturer was notified of the failure and the contact was informed that the vehicle was not included in NHTSA Campaign Number: 16V925000 (Engine and Engine Cooling). The contact was then referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was 98,403.

Jul 28, 2025

The contact owns a 2017 Ford Explorer. The contact stated that while the vehicle was idling, the temperature gauge indicated that the engine was overheating. After a visual inspection of the engine compartment, the contact observed that the coolant reservoir was almost empty, even though the vehicle had just been serviced. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the water pump. The vehicle was repaired. The contact also stated that the water pump had failed and was replaced in February 2023. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 192,000.

Jul 15, 2025

+ 52 more complaints for this component

WHEELS

42 complaints

The contact owns a 2017 Ford Explorer. The contact stated that while the vehicle was parked, the contact attempted to change the tires on the vehicle and was unable to remove the lug nuts. The contact stated that the lug nuts on all four wheels were swollen. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 176,825.

Jul 02, 2025

The right front passenger tire fell off while driving.

Feb 04, 2022

While driving on the freeway, I heard a clunking noise from the rear of my vehicle and immediately started to fishtail violently back and forth across all 3 lanes of the highway narrowly avoiding crashing into other cars on the highway while avoiding spinning or flipping the vehicle. I was able to gain control of the vehicle while it whipsawed back and forth with all four tires screeching and smoking slowing down to navigate to the shoulder out of harms way. It was one of if not the most frightening experiences I ever had as a motor vehicle operator. On inspection, I observed the rear left wheel was loosely connected to the drive train and severly out of alignment by ~30% which was what caused the vehicle to begin to fishtail and whipsaw so violently at freeway speed which at the time of mechanical failure was approximately 70 miles per hour. The road was clear, dry and void of any debris in the road.

Jul 29, 2021

WHILE DRIVING ON A STRAIGHT STREET 25-35 MPH JULY 30, 2020, ON A SUNNY DAY,MY CAR RIGHT PASSENGER TIRE CAME OFF. ON A CITY STREET. CAUSING MY CAR TO HIT THE CURB. THERE WAS NO BODY DAMAGE EXCEPT FOR THE PASSENGER FRONT AND REAR TIRE.

May 07, 2021

MY 2017 FORD EXPLORER HAS 19,000 MILES ON IT AND HAS BEEN MAINTAINED WELL. IT WAS OUTFITTED WITH HANKOOK VENTUS S1 NOBLES 255/50R20 TIRES WHEN WE PURCHASED IT NEW IN DEC 2017. THE TREAD HAS WORN DOWN TO 4/32NDS AND IS DISINTEGRATING-YOU CAN PEEL LITTLE BITS OF RUBBER OFF OF THEM. THEY ARE ALL WEARING EVENLY SO IT IS NOT AN ISSUE WITH LACK OF ROTATION/ALIGNMENT THERE ARE MOVIES ON YOUTUBE AND OTHER REVIEWS OF PEOPLE COMPLAINING ABOUT THIS ISSUE. HANKOOK IS ALSO AWARE THIS IS AN ISSUE AND IS DOING A VOLUNTARY PROGRAM WHERE THEY WILL GIVE YOU A PRORATED DEAL ON NEW HANKOOK TIRES. THESE TIRES NEED TO BE FULLY RECALLED AND HANKOOK NEEDS TO BE FORCED TO GIVE PEOPLE A PRORATED REFUND TO PURCHASE OTHER BRANDS OF TIRES NOT NEW VERSIONS OF THEIR PIECE OF CRAP PRODUCT. WE ARE NEEDING TO SPEND $1000 ON NEW TIRES FOR THIS OTHERWISE WONDERFUL VEHICLE.

Feb 15, 2020

+ 37 more complaints for this component

STEERING

39 complaints

I am reporting a safety-related defect involving the electric power steering system on my 2017 Ford Explorer. The vehicle displays a “Steering System Fault” warning, and when this occurs the power steering assist is reduced or disabled, creating a safety risk during low-speed driving, turning, and parking. When the ignition is on with the engine off, multiple communication fault codes appear, including U0100, U0131, U0140, and U0151. After the engine is started, these communication codes disappear, but the steering fault warning remains illuminated and no active fault codes are stored. This behavior indicates the steering system enters a fail-safe state during startup and does not recover. The battery was tested and replaced. Fuses, relays, wiring, grounds, and voltage drop during engine cranking were checked and found to be normal. Steering system reset and relearn procedures were performed using diagnostic tools, but the issue persisted. No external electrical or communication network problems were identified. Based on these findings, the problem appears to be an internal failure of the electric power steering rack or its control module. The loss or reduction of steering assist can occur without warning and increases the risk of a crash. This issue is commonly reported on 2016–2018 Ford Explorer vehicles, suggesting a design or durability defect. I am submitting this complaint to request that NHTSA investigate this condition as a potential safety defect.

Dec 13, 2025

The power steering went out with no warning. Stirring wheel went stiff and made it extremely hard to turn. All the traction and steering lights came on.

Nov 16, 2025

Problem with the power steering. When turning to the right, the wheel sticks. I have to forces it past the parts that sticks. This happens at low and high speeds. 68,569 miles all maintenance done at Ford dealership.

Nov 12, 2025

My daughter was driving our 2017 Ford Explorer when the steering wheel locked up without warning, putting her life at risk. It mirrors the exact steering rack failure already recalled for 2011–2013 Explorers (Recall #14S06 / NHTSA 14V286000). We were told by a certified mechanic that the steering rack and gear failed, and that this is a common issue in these models. Ford has opened Case #xxx-xxx, but refuses to take responsibility or escalate the matter. They acknowledge several other recalls on this vehicle, but not the steering system — even though multiple 2016–2017 Explorer owners report similar failures. This is a serious safety hazard that could result in death. I am requesting an immediate NHTSA investigation into expanding the current steering rack recall to include 2017 model Explorers. Please escalate this complaint and notify me of any developments. I am collecting evidence and testimony from other Explorer owners with the same issue.

Nov 03, 2025

Problem with the power steering. When turning, the wheel sticks.

May 10, 2025

+ 34 more complaints for this component

SUSPENSION

26 complaints

Cars rear end sways all over the place almost spun out on highway. I did some research and saw numerous recalls on the toe link in the rear of vehicle and have a good feeling its faulty again. I see it was replaced numerous times do to recall. Was wondering if there's like a warranty on recall work done

Dec 04, 2025

AFTER REAR TOE LINK REPLACEMENT DUE TO SAFETY RECALL, THE CAMBER CAUSES THE WEAR ON THE OUTSIDE OF THE REAR TIRES TO INCREASE DRASTICALLY. EVEN AFTER SEVERAL ALIGNMENTS THE CAMBER CAN NOT BE ADJUSTED SO THE WEAR CONTINUES.

Mar 07, 2025

The contact owns a 2017 Ford Explorer. The contact stated while driving at an undisclosed speed, the vehicle became difficult to control. The contact then noticed that the tire wear was uneven. There was no warning light illuminated. The contact was able to restart the vehicle. The contact received notification of NHTSA Campaign Number: 21V537000 (Suspension). The vehicle was taken to an independent mechanic where it was diagnosed that the front and rear alignment had failed and needed to be performed again. The vehicle received the front alignment, but the rear alignment was not performed. The mechanic referred the contact to the dealer for additional assistance. The dealer was contacted but the vehicle was not diagnosed or repaired. The contact was provided an estimate for the rear alignment. The manufacturer was made aware of the failure. The failure mileage was approximately 96,000.

Nov 25, 2024

Brought vehicle in for a recalled issue concerning the rear toe. After the repair, had accelerated tire wear in a month. Replaced the tires 3x in 2 years and the issue is still there. Currently tires are needed again for 4th time in 2 years.

Nov 02, 2024

The contact owns a 2017 Ford Explorer. The contact stated while driving at an undisclosed speed, the driver's side rear toe link fractured. The contact stated that the rear end of the vehicle swerved to the left. The contact stated that it was difficult to control the vehicle. The vehicle was driven to the shoulder of the roadway. The contact exited the vehicle. The contact stated upon inspecting the vehicle, the contact noticed that the driver's side rear suspension was on the ground underneath the vehicle. The vehicle was towed to the dealer, where it was diagnosed with a fractured driver's side rear toe link. The contact was informed that the driver's side rear toe link needed to be replaced. The vehicle was not repaired. In addition, the contact was informed that the ABS and the wheel bearing needed to be replaced prior to the recall repair being performed. The contact had received notification NHTSA Campaign Number: 21V537000 (Suspension); however, the contact was advised that the ABS and the wheel bearing needed to be replaced prior to the recall repair being performed. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 92,500.

Oct 31, 2024

+ 21 more complaints for this component

ELECTRICAL SYSTEM

25 complaints

Odometer Fraud. The contact purchased a 2017 Ford Explorer. The contact stated that while having an Emission test performed on the vehicle to have the vehicle registered, the test discovered that there was a mileage discrepancy. Upon purchase of the vehicle, the contact was provided a Carfax report that stated that the mileage was 103,000. The vehicle was a dealer sale purchased on November 23, 2025. At the time of purchase, the vehicle mileage was approximately 103,000 and it was later discovered that the mileage was 243,402.

Dec 10, 2025

Odometer Fraud. The contact purchased a 2017 Ford Explorer. The contact discovered that there was a mileage discrepancy after the purchase. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 58,000. It was later discovered, upon checking with a local independent mechanic, that the mileage had been altered; however, unknown.

Nov 17, 2025

The contact owns a 2017 Ford Explorer. The contact stated that at start up, the contact became aware that the ON/OFF ignition switch was fractured, and a half of the ignition switch was missing. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the ignition switch. The vehicle was repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was unknown.

Oct 16, 2025

We notice we were getting a warning about our battery about a year ago, so we took it to Ford and they said they couldn’t find any issues. We found a mechanic in town who looked at it with a volt meter an instantly noticed that the red power cable coming from the battery had burst through the casing that once held it. Now we have an exposed power cable that could potentially catch on fire if fluids from the engine were exposed to it. We first knew something was wrong when the doors would not unlock properly. And while driving we would get a battery warning. Ford told us during our warranty period that they didn’t find anything wrong when this should have been noticed instantly. This is a serious fire hazard. The vehicle was inspected by the manufacturer but a lack of knowledge by their mechanics has led to us filling this report.

Aug 10, 2024

Fire: 1

The contact owns a 2017 Ford Explorer. The contact stated that the speedometer and RPM gauges were sticking. There was an abnormal ticking sound detected. While in gear, the speedometer and RPM were flashing on and off. The driver was unable to determine the speed of the vehicle while driving. The contact stated that several unknown warning lights were flashing on and off. The contact disconnected the battery. The contact cleaned the cables and terminals and replaced the battery. The vehicle started working as designed, but the failure recurred. The contact called the local dealer, who scheduled an appointment. The vehicle was not yet diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 119,000.

Jun 21, 2024

+ 20 more complaints for this component

STRUCTURE,UNKNOWN OR OTHER

25 complaints

Vehicle: 2017 Ford Explorer Issue: Hood paint peeling / paint delamination Component: Exterior / Structure / Body / Paint Safety Concern: Corrosion risk and impaired visibility Description: The paint on the hood of my 2017 Ford Explorer is peeling and delaminating down to the bare aluminum, starting at the front edge and spreading across the hood. This is a known and widespread issue on 2013–2018 Ford Explorers involving defective paint adhesion on aluminum body panels. Ford previously issued TSB 17-0062 and Customer Satisfaction Program 19N01 addressing this exact problem. My vehicle is experiencing the same failure pattern described in these bulletins. The paint peels off in sheets, exposing bare metal to corrosion. This creates a safety concern because corrosion in this area can weaken the structure, and loose/chipped paint can detach while driving. Ford dealers acknowledge the issue but state that the program has expired, even though the defect continues to occur. This appears to be a manufacturing defect that affects a large number of Ford vehicles and needs further investigation and manufacturer accountability, dependability and loyalty, positivity and innovation (which happen to be FORD’s Core Values)to solve the manufacturers defect problems. Further service concerns at Michigan City Ford Dealership include: 1. Previously scheduled oil change, nobody present on the building except 1 guy at back desk down hallway watching YouTube videos, didn’t know where my key was, after searching, located my key and unaware that the oil change had not occurred until I brought it up, Ford employee asked if I would like to reschedule without apology, I declined. 2. A pillar recall: only half repaired on 11/17/2025 due to not properly ordering all parts after multiple inspections. Advisor said he would be “stealing” the parts from another customers appointment to finish A pillar recall on 11/19/2025. More time and energy cost to customer due to lack of accountability.

Nov 19, 2025

The B pillar trim pieces from the recall have not been fixed. They are, in fact, detached and do make noise while driving. I have called fords in the area multiple times and they do not know when they will have parts.

Sep 11, 2025

Front window trim/ A pillar detached while driving on October 18,2024. Contacted dealership for replacement at the end of October 2024, and each month following, they brought vehicle in for inspection but have never replaced the trim piece. It has now been 9 months, I have called the dealer every month to follow up and have been told every time they still do not have the part to fix it. I am concerned that the trim on the other side of the car could fly off and cause damage to my vehicle or others.

Jul 13, 2025

Water leaking in the drivers side frame that goes down the inner column by the dash onto the floor board, leaks above the driver visor, and in the back frame in the trunk of driver side. I have had it checked over by a Ford dealer twice and they claim it was my sun roof-which it is not. When I tried to have it checked again with a non Ford mechanic, it’s been too cold and rainy so the problem cannot be found. It has gotten worse in my car, water damage to the dash and I get condensation that forms on the inside of my windshield. Thought it occurred due to the windshield guard cover recall but that isn’t the case.

Dec 18, 2024

The exterior "door entry keypad pillar molding trim" became detached from the vehicle and sent debris into the roadway while traveling on the highway. This component is the door access keypad found on the drivers side door of many Ford vehicles.

Aug 23, 2024

+ 20 more complaints for this component

VISIBILITY/WIPER

23 complaints

The weather stripping/seals around the windshield are crumbling/cracking and fly off the vehicle while driving and when loose create wind noise/rattle. Both sides and base near hood called a cowl I believe. Dealer indicated the cowl and trim could be replaced but would require significant labor and was not part of the A pillar recall. I asked if windshield was at risk or if it was just cosmetic and was advised no safety concern.

Oct 09, 2025

This recall has been out for over a year and a half and I still do not have parts. It is LOUD in my car. At what point, can I get it fixed myself and charge it back to ford? thank you

Jul 28, 2025

The windshield wipers on my 2017 Ford Explorer will not turn off, when the vehicle is. Of course the wiper switch is in the OFF position and it persists. This issue began without warning and continues consistently. This is distracting, obstructing my vision, and giving me a headache every time I get in my car. This potentially dangerous while driving, especially in dry conditions where the wipers can damage the windshield or reduce visibility by smearing debris. Based on online forums and other owner reports, this appears to be a common issue affecting many 2017 Ford Explorer owners. It also seems to be common in early models of the same generation meaning it has been a known issue and hasn’t been resolved. This should be investigated as a potential manufacturing defect. A malfunctioning wiper system can create a hazardous driving condition and may warrant a recall

Mar 26, 2025

Safety Recall Notice 24S02 / NHTSA Recall 24V031 for my 2017 Explorer was done in January 2024 and I received the letter in February 2024. The parts still aren't available after 9 months which is unacceptable. I am now having to use long strips of duct tape on my windshield to hold these loose parts in place which affects my vision to drive and my windshield wipers to work correctly. I wasn't in any accident but concerned about what may happen. This has been going on since July 2024 when I went to the beach and we were going down interstate the piece came loose. We have been using duct tape since that has to be replaced weekly Nothing should take this long and replacements parts need to be made available to repair as soon as possible.

Oct 09, 2024

My windshield and windows collect condensation inside the vehicle during the winter and cold months. This occurs continuously while vehicle is in use and it causes me to not be able to see out my windows or windshield while driving.

Dec 09, 2023

+ 18 more complaints for this component

VISIBILITY

23 complaints

The contact owns a 2017 Ford Explorer. The contact stated that the air conditioner system blew out hot air when activated. As a result, the children in the vehicle felt overwhelmed by the impact of the heat while driving in hot weather conditions. The contact mentioned living in a hot climate state. The vehicle was taken to a local dealer where it was diagnosed that the A/C condenser needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 96,000.

May 13, 2024

The front windshield gasket on our 2017 Explorer is disintegrating, cracked and brittle. Today a chunk broke off as I was driving.

Oct 21, 2023

The contact owns a 2017 Ford Explorer. The contact stated that while driving at an undisclosed speed, the front windshield molding separated and detached from the vehicle. The vehicle was taken to the dealer where it was informed that the parts needed to complete the repair were out of stock. The vehicle was not repaired. The manufacturer was made aware of the failure and advised to contact the NHTSA Hotline. The failure mileage was approximately 80,000.

Oct 10, 2023

I was driving at highway speed today, and the drivers side windshield pillar plastic trim broke free from the vehicle and flew in the air towards following traffic

Sep 22, 2023

The contact owns a 2017 Ford Explorer. The contact stated while driving 60 MPH, she heard an abnormal sound and noticed that the sunroof glass panel had shattered without impact. The contact took the vehicle to the local dealer, where it was diagnosed with needing the sunroof glass panel to be replaced. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 71,000.

May 22, 2023

+ 18 more complaints for this component

UNKNOWN OR OTHER,ENGINE

21 complaints

There is an odor in the passenger cabin. Seems unsafe

Dec 03, 2025

Engine block timing plate cover has a defect crack in it causing an oil leak and fire hazard.

May 10, 2025

Car wouldn't start. All the water had run out due to coolent leak near water pump and in finding it they found leak near front engine mount. These are problems that other 2017 explorer owners have also complained about online. In addition, Kirkland Ford stated they are backed up on repairing the toe link and roof repair due to lack of certified mechanics. The 2017 whole vehicle should have been recalled due to the cheap parts used which has caused me to continually go in to have recalls fixed. While there they end up causing more issues causing me thousands in repair bills. I have scheduled with independent car repair shop for them to give me estimate of repairing the above items for January 10 the first date they had available.

Dec 27, 2023

Water pump failed and coolant leaked into the engine

Jul 03, 2022

GETTING BAD HEADACHES AND FEELING SLEEPY WHEN DRIVING MY FORD EXPLORER DON'T LIKE HAVING MY 7MONTH OLD IN THE CAR.

Jun 29, 2019

+ 16 more complaints for this component

AIR BAGS

16 complaints

The contact owned a 2017 Ford Explorer. The contact stated that while his wife was driving at 15 MPH traveling southbound, the occupant of a Chevrolet Impala driving at approximately 55 MPH allegedly fell asleep, veered into her lane, and crashed into the driver's front end. There were no warning lights illuminated. The steering wheel was bent three inches toward the dashboard. The transmission was fractured during impact. The contact mentioned that the airbag deployed late and may have been too powerful. The impact forced the vehicle back about 40 feet. The driver sustained injuries resulting in broken rib bones, a broken sternum bone, and four herniated discs, and medical attention was provided. A police report was filed. There was no reported fire. The vehicle was towed to the auction lot. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage is approximately 135,000. The vehicle was deemed a total loss by the insurance company. The VIN was not available.

Oct 03, 2025

Crash: 1

Injuries: 1

The contact owns a 2017 Ford Explorer. The contact stated that while driving at an undisclosed speed, the air bag warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed, and determined that the wiring harness located on the passenger’s side of the vehicle had failed and needed to be replaced. The vehicle was repaired; however, the failure recurred. The manufacturer was made aware of the failure. The failure mileage was approximately 57,737.

Sep 08, 2025

The contact owns a 2017 Ford Explorer. The contact stated that the rear driver’s side air bag warning light was intermittently illuminated while driving at various speeds. The vehicle was taken to the dealer for a diagnostic, and the contact was informed that the air bag wiring harness needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure,e and a case was filed. The contact was then referred to the NHTSA Hotline to report the failure. The failure mileage was 45,000.

May 05, 2025

The air bag light is illuminated as a result of a worn/damaged connection to the rear inflatable seat belt connector.

Apr 15, 2025

The airbag light on my vehicle comes on quite often. If there is a passenger sitting in the seat, it tells me that the airbags off. Nothing has happened yet but if the airbag doesn’t go during your crash, could cause severe injury. Can be inspected but plan to see what issue is and have it fixed soon.

Jan 13, 2025

+ 11 more complaints for this component

FUEL/PROPULSION SYSTEM

16 complaints

Water pump failure, causing over heating in vehicle , not even 100,000miles. Causing to leave us stranded on the road. Apparently there's a lot of complains for this pump causing issues. Please look into this and start a recall process.

Apr 29, 2025

FUEL TANK LEAK. Heavy odor of gasoline when tank full. Independent mechanic checked for cause and observed residue around the tank where gasoline had escaped from top of tank. Ford Dealership did a diagnosis and subsequent repair, finding that gasket, on top of the tank at the sending unit/fuel pump had cracked, allowing gasoline and fumes to escape. The position is in immediate proximity of the vehicle exhaust pipes. - Repaired by Ford Dealership as an absolute necessity for safety, to avoid a potential fire from gasoline dripping on exhaust pipes either while in motion or parked.

May 30, 2024

Apparently Ford is aware that there is a know issue with the Ford Explorer Water Pump failure which is causing water pump leakage inside engine mixing coolant and oil. This has been reported by thousands of consumers who are faced with an average cost of about $3000 to get this resolved. This should be considered a recall.

Nov 18, 2023

WATER PUMP LEAKING

Jul 17, 2023

fuel vapor purge valve keeps going out or sticking causing RPMS to rev up, vehicle has shut off while driving.

Jul 11, 2023

+ 11 more complaints for this component

SEAT BELTS

13 complaints

Rear passenger side seat belt strap is twisted and stuck in fully extended position.

Dec 04, 2025

The contact owns a 2017 Ford Explorer. The contact stated that while attempting to use the 2nd row seat belts, after further inspection, the 2nd row driver’s side seat belt buckle remained latched and failed to release from the buckle and the 2nd row passenger side seat belt failed to latch securely as intended. The vehicle was taken to a local dealer; however, parts were not yet available to repair the vehicle, and the warranty was not valid. The manufacturer was made aware of the failure. The failure mileage was approximately 85,000.

Jun 25, 2025

Passenger side/right side second row bucket seat = seat belt broke. Called numerous dealerships and were on a waiting list of over 350 that need a seatbelt. No seat belts available. Unable to fix problem. Safety issue due to no seat belt. No warning lamps or messages.

Apr 11, 2025

In a 2017 Ford Explorer Platinum the passenger 2nd row seatbelt malfunctions and will not extend. It is available for inspection. The seatbelt first binded (or became stuck) March 2024 and taken into Ford dealership and they reported "Upon inspection of seat belt, found to be internally binding at the retractor. Requires replacement." They ordered replacement but said it was on backorder, it took months before replacement arrived. When replacement arrived it was taken in to Ford dealership to replace but Ford reported "Replaced RR seat belt retractor. After installation, found a faulty part was sent. Reinstalled old seat belt and ordered new belt." Returned to Ford dealership for the second replacement seatbelt and it was installed and at time was working. Now for the third time (During the next several months after the third seatbelt is installed) it has gotten stuck (binded) and unable to extend several times and unusable. Resulting in having to relocate the passenger to another seat. Safety concern: users may not have a working and reliable seatbelt. Passenger may not be restrained with seatbelt or it may force a child from sitting in the rear seat to relocate to a more dangerous front seat due to lack of working seatbelts. This seems to show that the seatbelt mechanism must be defective in that 3 seatbelts are having similar problem in a 6-12 month window. Have also seen similar reports of this issue on Reddit.

Feb 08, 2025

2017 FORD EXPLORER. CONSUMER STATED THAT THE SEATBELT BUCKLE WOULD NOT RELEASE. THE CONSUMER STATED TOOK THE VEHICLE TO BE REPAIRED THE DEALER LOST THE STEP PANEL AND ALSO NEED ADDITIONAL PARTS TO INSTALL THE NEW SEATBELT.

Jan 11, 2023

+ 8 more complaints for this component

TIRES

13 complaints

Hankook Ventus S1 Noble 2 P255R20 A/S BSW Tires 23,041 miles 2017 Ford Explorer Sport. These are the tires that came on the vehicle, there is only 23,041 miles on the vehicle and the tires are prematurely wearing on the outerside of all 4 tires. Chunks of the tire is pealing off. Hazardous to drive. The vehicle is not out of line, tires are rotated on schedule, and tire pressure maintained. Looks like defective tires, need to be investigated as safety recall. Ford Motor Company is aware of the problem and stated that we need they have a problem with those tires pealing and wearing out, most people have to replace around 20,000 to 30,000 miles. VERY DANGEROUS! I have safety inspections that shows tire are perfect.

Jun 14, 2023

On 5/21/2021 a Police Officer for the Iowa Tribe Police Department located in Perkins, Oklahoma was responding to a call and had just been canceled when the driver-side rear tire tread separated from the tire and it blew out. The officer's safety was at risk had she not been canceled and slowed down some or this could've resulted in a rollover or some other traffic collision possibly injuring or killing the officer or other individuals on the roadway. Direct Discount Tire in Stillwater Oklahoma is unaware of any recalls with this tire and have offered to help replace the tire. The tire hasn't been inspected by the manufacturer as I am unaware who manufactured this tire. Upon researching Nokian tire through the internet I discovered that Nokian Tires have had issues in the past for tread separation. The earliest I could fine may have been around 2016. There were no warning lamps and these tires were purchased and put on this vehicle brand new since February 2021. My concern is that there may be a manufacture default causing these tires to have tread separation. I am concerned because this is the brand of tire recommended for police unit bu Direct Discount. I am concerned an officer could be injured or killed in a crash if this is a defect by the manufacturer and we are getting much needed patrol vehicle tore up in the process.

May 24, 2021

THE VEHICLE AND ITS WHEELS WITH ONLY 16,000 MILES HAS DEEP CRACKS AND CUTS ON THE SIDES OF THE TREAD, THREATENING FUTURE BREAKAGE OR EXPLOSION. AS FOREMENTIONED THE VEHICLE UNDERGOES REGULAR MAINTENANCE AS WELL TIRE ROTATION. THERE IS NO REASON FOR THE WHEELS TO BE THIS DAMAGED WITH SO LITTLE USE. TIRES: HANKOOK TIPE: VENTUS S1 NOBLE SIZE: 255 150/20 105H DOT 5MNC 1A H (1817) QUANTITY : 5

Apr 30, 2021

FIRST COMPLAINT IS THE PAINT IS PEELING AND BUBBLES FROM THE FRONT OF HOOD. THIS WAS FIXED BY FORD 1 YEAR AGO AND TOLD WAS NOT SURE WHY THIS WAS HAPPENING. NOW AGAIN ALL ALONG HOOD AT FRONT SAME PROBLEMS. *TR SECOND COMPLAINT. THE REAR TIRES ARE WEARING AT THE OUTSIDE AND INSIDE OF TREAD. THE DRIVERS SIDE SEEMS TO BE WORSE. IT NEEDS TIRES NOW DUE TO SAFETY CONCERNS THAT I KNOW HAVE. THE VEHICLE SEEMS TO BE UNSTEADY AT GRADE CHANGES IN ROADWAY ESPECIALLY ON THE FREEWAY.

Jun 25, 2020

VEHICLE VIBRATION AT 60 MPH. SERVICE DEPARTMENT DID INSTALLED "ROAD ANALYZER" AND PERFORMED "NVH DIAGNOSTICS". ALL TIRES BALANCED WITHIN 1/4 OZ, FOUND TWO REAR TIRES WITH 5015 MILES ON VEHICLE TO HAVE ROAD ROAD FORCE OF 18-20 LBS ON EACH OF THE REAR TIRES. DIAGNOSIS REPLACE TIRES!

Dec 24, 2019

+ 8 more complaints for this component

POWER TRAIN,ENGINE

12 complaints

I periodically have unintended acceleration ; it has occurred off and on for the past two years . The Ford dealer said no faults were detected so they can't fix the problem . It most often when I am shifting into reverse then the RPMs increase dramatically and when I put it in neutral they shoot up even more . A few days ago I was putting the car into the garage , waiting for the door to open , with my foot on the brake and the shift in drive when the RPMs started to increase . Feeling the car starting to move I shifted to neutral when the RPMs shot up tremendously . This is a dangerous situation where someone can get injured or killed . Ford should be able to correct the problem !!!

Jun 11, 2025

The contact owns a 2017 Ford Explorer. The contact stated while driving at various speeds, the vehicle made an abnormal clunking sound, went into LIMP Mode, and failed to exceed 25 MPH. The check engine warning light was illuminated. The contact shifted to reverse(R), but the vehicle failed to respond. The contact called the independent mechanic whom the vehicle was purchased from, but no assistance was provided. The vehicle was taken to a local dealer, where it was diagnosed with catastrophic transmission damage. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. There was no warranty coverage on the vehicle for the failure. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 145,000.

Apr 04, 2025

I have a 2017 Ford Explorer with a water pump that needs replacing per a Ford dealership. It has 59K. It should last at least 150k. There should be a recall as there are thousands of these vehicles with the internal water pump. Apparently it's a problem if they are no longer making them internal. I want to file a complaint and would like some type of compensation.

Dec 02, 2024

I have replaced all the starter coil packs in my engine and still have the same problem the codes read misfiring on multiple cylinders wich causes the car to lose power and pull back on the transmission while pushing on the gas pedal this is an ongoing problem

Mar 30, 2024

Since owning vehicle with around 60k, 2 serpentine belts have been replaced, high pressure hose replaced, water pump is now failing. Looking online, this vehicle has been plagued with issues and no recalls? A failing water pump from 2011 models on? Not sure how a car can have over $10k in problems and no recalls.

Feb 28, 2024

+ 7 more complaints for this component

ELECTRICAL SYSTEM,UNKNOWN OR OTHER

8 complaints

I recently found out about a Ford recall regarding the backup cameras malfunctioning which did not include my vehicle even though my vehicle is showing the unsafe defect. The backup camera goes fuzzy/glitchy as well as black sometimes while backing up.

Sep 11, 2025

The sunroof gets stuck in the tilted open position and sunshades will not close. This creates an unsafe condition if it starts to rain. Cannot secure the vehicle. This problem is very common and there are many complaints and how to fix videos on the internet. I contacted Ford At first they were cooperative and offered to help with the repair. Then suddenly they refused to help with the repair. This left me with a 1200.00 bill at the dealer. It is a common failure, it was occurring on the previous model year and was not addressed, it requires proprietary tools to fix. There is low incentive to Ford to fix if they can make a profit from the failure. just one online example there are many videos and how to repair post and complaints: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Apr 07, 2025

Keyless entry panel on driver's side continues to fall off while driving, hanging by wires, which then blow fuses. Lift gate ajar warning comes on and then unable to open/close rear lift gate. Indoor overhead lighting remains on due to "liftgate ajar" even though liftgate is not ajar. This is a Safety hazard, panel could fly off during driving. Took to dealer, misdiagnosed as liftgate latch malfunction. Paid to get latch replaced and one week later, keyless entry panel fell off again and liftgate ajar warning came up and unable to open or close liftgate and interior lighting remains on.

Jan 16, 2025

Like the existing recall for the exterior A pillar , the exterior B Pillar is lifting from the car at the top. This has since caused rain water to leak in from the top and caused a short in the touch entry keypad within the pillar, causing it to flash on and off over and over draining the cars battery until it is dead and won’t start.

May 28, 2024

My locks on my doors will not lock with keyfob or when I push my lock button in the car. I am scared that if I can't lock them someone will fall out the car. Someone can steal my car because I cannot lock my doors.

Apr 29, 2024

+ 3 more complaints for this component

SERVICE BRAKES

8 complaints

The inside rear brake pads sustained a 66% loss of material in 9260 miles of normal driving. The vehicle was serviced on 10-03-23, 53,446 miles, the fronts pads had 7mm and the rears had 6mm. The vehicle was again service on 09-11-24, 62,706 miles, the front pads had 6mm and the rear had 2mm. I had the dealer take the rear brakes apart and check everything for why the pads wore down so fast. The findings were that all components were in good working order and the outside rear pads actually had 5mm and the inside rear pads had 2mm.The dealer told me they couldn't find a problem as to the extreme wear. I contacted Ford and they couldn't or wouldn't help due to no problem found and brakes being a wear related part. All work was performed at Lithia Ford of Boise.

Sep 26, 2024

Car wouldn't stop or slow down until I put all my pressure on the pedal. No previous warning about brake issues. No lights or sounds regarding brake problems.

Sep 25, 2023

While backing out of our driveway the car started speeding up and the brakes failed. Even with repeated pumping of brakes the car wouldn’t stop. We finally jammed the shift lever into park and even then it continue moving for a short distance. We wiped out our neighbors mailbox. It did the same thing yesterday but we thought my husband accidentally hit the gas instead of the brake. Today we know it was the car.

Jul 10, 2022

Crash: 1

This vehicle is equipped with an Anti-lock brakes. On Sunday, while driving slowly through a slippery parking lot, due to ice, my brakes locked in the downward position. I was not able to get the brakes to function. This resulted in a low impact auto accident.

Jan 12, 2022

Crash: 1

When vehicle is cold the brake pedal is normal 2inches movement. After 10 miles or so the pedal moves 4or 5 inches. After the vehicle cools down again the pedal returns to 2 inches again. The ford dealer does not know what the problem is.

Oct 22, 2021

+ 3 more complaints for this component

SEATS

8 complaints

The contact owns a 2017 Ford Explorer. The contacted stated while reaching down between the driver's front side of the seat to retrieve an item, the sharp edge of the seat frame cut her hand. The contact also stated that several passengers had cut their hands while retrieving an item from the passenger’s side front seat. The vehicle was taken to the dealer. The vehicle was repaired under NHTSA Campaign Number: 19V651000 (Seats) however, the failure persisted. The manufacturer was made aware of the failure but transferred the contact to the NHTSA Hotline. The approximate failure mileage was 34,000.

Jan 19, 2024

My driver-side seat has a hole beginning from the midway left side due to the stitching coming apart. My dealer service rep was made aware of this issue and has told me it's not covered under any warranty. I feel it will become a serious safety issue because it contains the side impact airbag system devices that are enclosed in the area where the stitching is coming apart. I was also told it would cost me money to fix it. I do not feel that I should bear the financial burden to repair this problem due to faulty stitching. My service rep told me that 3 other vehicles came into the dealership with similar problems. I am willing for a Ford Motor company district service rep to inspect it and give me an acceptable solution to this dangerous issue. There was no warning of this problem. My vehicle only has 27000 miles on it! I have owned other vehicles with high mileages on them and NEVER had a seat become unstitched.

Aug 21, 2021

THE FRONT DRIVER SEAT FEELS LOOSE. WHEN DRIVING AND TAKING A SHARP CURVE OR GOING OVER BUMPS THE SEAT SHIFTS.

Dec 01, 2020

I NOTICED A STRANGE NOISE WHEN I MADE TURNS AND IT FELT AS IF MY DRIVER SEAT MADE A SLIGHT MOVEMENT. WHEN THE DEALERSHIP FINALLY LOOKED AT IT THOROUGHLY AFTER 3 TIMES THEY DETERMINED THE BAR UNDER MY SEAT THAT BASICALLY HOLDS MY SEAT IN PLACE WAS BROKE COMPLETELY IN HALF. NO EXPLANATION. THE CAR HAS NEVER BEEN IN AN ACCIDENT AND HAS LESS THAN 50,000 MI ON IT. THEY STATED THEY HAVE NEVER SEEN ANYTHING LIKE IT CHARGED ME THE DEDUCTIBLE AND FIXED IT MY CONCERN IS THAT IT WAS A MANUFACTURING PROBLEM AND IF IT HADN'T NOTICED IT AND HAD AN ACCIDENT I FELT LIKE MY SEAT WOULD HAVE DETACHED. IT WAS A LITTLE SCARY AND DISCONCERTING.

Nov 12, 2020

DRIVERS SIDE HEATED SEAT NOT WORKING , TRUCK ONLY HAS 34624 MILES .DIAG CODE B1034:40 , DEALER WILL NOT REPAIR OUT OF WARRANTY

Mar 11, 2020

+ 3 more complaints for this component

ENGINE AND ENGINE COOLING,ENGINE

7 complaints

The contact owns a 2017 Ford Explorer. The contact stated that after the battery had been replaced, the vehicle failed to start. The vehicle was jumpstarted several times. The contact stated while driving 60-70 MPH and attempting to overtake another vehicle, the vehicle failed to respond upon depressing the accelerator pedal. The contact returned to the initial lane. The contact stated that the failure recurred several times while driving. The contact stated while the vehicle was parked in front of the residence, the contact noticed that coolant had leaked from the vehicle onto the ground. The contact stated while driving at an undisclosed speed, the engine was overheating. The check engine warning light was illuminated. The vehicle was taken to a Chevrolet dealer, where the contact was informed that there was no coolant in the coolant reservoir and the mechanic determined that the water pump was leaking. The dealer added coolant and water to the vehicle. The contact stated that the engine continued to overheat while driving. The vehicle was taken to Christian Brothers, where it was diagnosed that the water pump and the timing chain needed to be replaced. The vehicle was not repaired due to the cost. The vehicle was towed to an independent mechanic, where the water pump was replaced. The vehicle was towed to another independent mechanic, where the contact was informed that the timing chain and the water pump needed to be replaced at the same time. The vehicle was being repaired. The dealer was notified of the failure. The contact stated that the independent mechanics and the dealer had informed the contact that the failures were common. The manufacturer was notified of the failure and a case was filed. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 90,000.

Mar 05, 2025

The contact owns a 2017 Ford Explorer. The contact stated that while parked with the engine idling the message "Engine Too Hot to Operate" was displayed and the engine temperature gauge indicated that the engine had overheated. The vehicle was towed to the local mechanic who diagnosed that the water pump and timing chain were faulty and needed to be replaced. The water pump and timing chain were replaced, and the vehicle was repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 132,000.

Aug 25, 2023

The contact owns a 2017 Ford Explorer. The contact took the vehicle to a dealer for routine maintenance and was informed by the service technician that the water pump was leaking coolant into an engine cylinder. The contact was provided an estimate for the repair. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 60,000.

Aug 07, 2023

The contact owns a 2017 Ford Explorer. The contact stated while driving 65-70 MPH, the engine seized. The contact was able to veer to the side of the roadway. The contact stated that upon attempting to restart the vehicle, the message "No Oil Pressure" was displayed. The vehicle was towed to the dealer, where it was diagnosed that the head gasket was blown, causing coolant and oil to mix. The dealer diagnosed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 141,000.

Jul 25, 2023

The contact owns a 2017 Ford Explorer. The contact stated that the engine overheating message was displayed on the instrument panel. Upon inspection, the contact discovered that the coolant level was low, and added coolant to the reservoir. The vehicle was taken to two independent mechanics and was informed that the water pump had failed, causing a coolant leak. The manufacturer was notified of the failure and referred the contact to the dealer for assistance. The vehicle was not repaired. The failure mileage was approximately 80,000.

Jun 08, 2023

+ 2 more complaints for this component

STRUCTURE,VISIBILITY/WIPER

6 complaints

So for starters the visibility wipers should have a auto wiper function as in when it detects rain they will automatically come on. Well they do but they also come on at random intervals even when it’s not raining. Secondly the glove box design is horribly engineered and it falls apart by its self. My glove box flew open while driving down the road and caused me to run off the roadway with my kids in the car. Luckily my kids and I are safe and no one was hurt but something should be done about this. The tension cord that hooks to the glove box just snapped from the looks of it.

Aug 06, 2025

Crash: 1

The top and bottom rubber of the windshield is corroded, falling off, and flapping against the windshield. It is also making a whistling noise and wind is coming into vehicle from the top. I was told that the recall would fix that but once they came to fix it they only did the left and right side of windows and left the rest the way it was. I expressed my concerns on a few occasions but they refused to fix it. I’m an elderly wheelchair bound female whose only transportation method is this vehicle. I have my daughter driving me to doctor’s appointments and the whole time I’m in the vehicle I’m afraid the windshield will fly off. The noise is so loud and hard to hear. The sun roof appears to be leaking as well so air could be seeping though there too. The windshield wipers go off by themselves even when it’s off or not raining. Even when the wipers are on there’s a big delay to wipe windows which makes it hard to see. I’m not sure if any of these issues are related but they have been brought to the attention of the manufacturer with no response.

Mar 11, 2025

The black trim/molding around the front windshield is breaking and perking off in chunks while driving on the freeway.

Feb 05, 2024

A piece of the driver side exterior column flew off and into windshield causing crack and poor visibility because of it.

Feb 04, 2024

The trim of our windshield flew off and almost caused an accident. Water got in and caused damage shortly after.

Oct 27, 2023

+ 1 more complaint for this component

TIRES,WHEELS

6 complaints

I PURCHASED A 2017 FORD EXPLORER XLT AND AFTER 20,000 MILES I WAS TOLD THE TIRES NEEDED TO BE REPLACED. I AGREE WITH THE SERVICE MAN AND AM LOOKING TO REPLACE THEM. I LOOKED AT THE TIRES, HANKOOK, VENOUS S1NOBLE 2, 255/50R20 105H AND SAW THE DOT DATE WAS 002881, 2012.. IF I'M READING THIS CORRECT THE TIRES WERE FIVE YEARS OLD UPON BUYING THE VEHICLE AND THEY ARE NOW SEVEN YEARS OLD WITH 20,000 MILES ON THEM. I BELIEVE THEY ARE UNSAFE AND WERE PROBABLE UNSAFE WHEN I BOUGHT THE VEHICLE

May 11, 2019

OEM HANKOOK TIRES ON 2017 FORD EXPLORER: WITH LESS THAN 15,000 MILES ON MY 2017 EXPLORER, IT BEGAN TO HYDROPLANE AT MUCH LOWER SPEEDS THAN WHEN NEW. THE TIRES ARE OEM, HANKOOK, VENTUS S1 NOBLE. I TOOK THE CAR TO FUGATE FORD, WHO SAID THEY RECENTLY PROCESSED TWO OTHER VEHICLES WITH BAD HANKOOK TIRES. ON CLOSER INSPECTION WITH DOUG AT FUGATE, YOU COULD SEE THE TIRE TREAD WAS RIPPING AWAY FROM ITSELF ALL THE WAY AROUND THE TIRE. FUGATE TOOK PICTURES AND PHONED HANKOOK. FUGATE CALLED ME TO SAY THAT BECAUSE THE TIRES HAD 6/32 TREAD REMAINING, THEY WOULD NOT PROCESS THE CLAIM. HANKOOK NEEDED THE TREAD WEAR TO BE 4/32 OR LESS. IN MY VIEW, THAT'S RIDICULOUS... THESE HANKOOK TIRES ARE DEFECTIVE AND UNSAFE, WHETHER AT 6/32 OR 4/32. TODAY, I HAD ALL FOUR DEFECTIVE TIRES REPLACED.

Jan 08, 2019

HANKOOK VENTUS S1 NOBLE2 (EXCLUDED FROM RECALL) ARE WEARING EXTRAORDINARY FAST AND THE RUBBER IS STARTING TO PULL APART, FLAKE AWAY. CHUCKS OF RUBBER ARE COMING OFF OF THE TIRE AND LEAVING HOLES THAT APPEAR TO BE ABOUT 1/4 INCH DEEP . THIS WILL BE OUR SECOND SET OF TIRES WITH THE SAME ISSUE AND THE VEHICLE HAS ONLY 40,000 MILES.

Nov 11, 2018

PURCHASED 2017 FORD EXPLORER FEBRUARY 2017 WITH ORIGINAL HANKOOK VENTUS S1 NOBLE2 255/50R20 105H TIRES. HAVE 20,000 MILES AND HAVE BEEN ROTATED AT EACH OIL CHANGE; HAVE BEEN EXPERIENCING LOW AIR PRESSURE READINGS, CHIPPING ON TIRES, AND EXTREME TREADWEAR. DEALER SUGGESTED TO CONTACT HANKOOK DIRECTLY BECAUSE OTHERS HAVE EXPERIENCED SIMILAR ISSUES. MANY ATTEMPTS TO CONTACT HANKOOK CUSTOMER SERVICE HAVE NOT BEEN SUCCESSFUL...THIS IS ANOTHER DANGEROUS ISSUE SIMILAR TO THE FIRESTONE DISASTER.

Oct 29, 2018

2017 FORD EXPLORER SPORT WITH HANKOOK 255/50R20 105H VENTUS S1 NOBLE 2 TIRES ARE CHIPPING/CUTTING AND WEARING PREMATURELY. VEHICLE ONLY HAS 12,500 MILES.

Jul 24, 2018

+ 1 more complaint for this component

STEERING,ELECTRICAL SYSTEM

5 complaints

I’ve been experiencing a buzzing sound whenever I turn the steering wheel, and the more I drive the vehicle, the louder the noise becomes. I took it to a local shop, and they advised me that the power steering rack is going bad — a very common issue in 2017–2019 Ford Explorers, especially around the 100,000-mile mark. They provided a quote of $2,652.86 to have it replaced. I was also warned that if it’s not replaced soon, the steering could lock up while driving, preventing me from turning the wheel, which poses a serious safety risk. No warning lights or dashboard messages have appeared, which makes the issue even more concerning.

Aug 07, 2025

The contact owns a 2017 Ford Explorer. The contact stated while driving approximately 10 MPH and making a right turn, the steering wheel did not return to center. The contact stated that the steering wheel failed to respond normally while turning the steering wheel to center. Additionally, the contact stated that the instrument cluster went black, and the vehicle stalled. The contact pulled over safely and restarted the vehicle. The contact stated that the “System Communication Error" message was displayed on the infotainment screen after the restart. The contact later had the vehicle towed to a local dealer, where it was diagnosed and determined that the wiring harness and the GWM harness needed to be replaced. The vehicle had been repaired. The contact stated that after the repair, the battery had started to drain very quickly. The vehicle was towed back to the same dealer but was not diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was 43,833.

Aug 11, 2023

The contact owns a 2017 Ford Explorer. The contact stated that while driving at an undisclosed speed and attempting to make a left turn, the steering wheel failed to respond. The contact shifted to park(P) and then shifted back into drive(D). The vehicle then regained steering functionality. The contact was able to continue driving however, the failure recurred on several occasions. The vehicle was taken to the local dealer on three occasions; however, the dealer was unable to duplicate the failure and the failure persisted. The manufacturer was notified of the failure and referred the contact to NHTSA Hotline for assistance. The failure mileage was approximately 30,676.

Sep 08, 2022

MY STEERING WHEEL WOULD BECOME VERY STICKY. I WOULD MAKE A TURN AND THEN WHEN I WOULD GO TO TURN THE WHEEL BACK, IT WOULD STICK. IT ALMOST THREW ME INTO A TRACTOR TRAILER YESTERDAY. I NOTICED IT MORE AT HIGH SPEEDS AND MOST TIMES IT WAS SOMETHING I COULD 'DEAL WITH', PLANNING AHEAD WHEN TURNING, SLOWING MY SPEED, ACCOUNTING FOR OVER CORRECTING THE WHEEL, BUT YESTERDAY WAS VERY SCARY. I FELT LIKE I HAD TO MAKE CONSTANT LITTLE TURNS WITH MY WHEEL EVEN THOUGH I WAS GOING PERFECTLY STRAIGHT. I PULLED OFF AND TURNED MY CAR OFF AND THEN TURNED IT BACK ON AND IT WAS AS NOTICEABLY NOT AS BAD. I TOOK IT STRAIGHT TO THE DEALERSHIP BECAUSE I'VE HAD IT FOR LESS THAN TWO MONTHS AND THEY INFORMED ME I NEED A NEW STEERING GEAR BOX. I WAS CONSTANTLY AFRAID OF OVER CORRECTING MY WHEEL TO ACCOMMODATE FOR THE STICKINESS OF IT AND ENDING UP IN THE OTHER LANE OR OFF THE SIDE OF THE ROAD.

Nov 05, 2020

VEHICLE HAS AN INTERMITTENT ISSUE WHERE IT WILL LOSE ALL POWER (STALL), AND ELECTRONIC COMPONENTS WILL INHERENT SPORADIC BEHAVIOR, FOR INSTANCE THE VEHICLE WILL REFUSE TO COMPLETELY SHUT-OFF. THE ERROR MESSAGE ON THE DASH SHOW "POWER STEERING ASSIST FAILURE". THIS TYPICALLY HAPPENS ON A DAILY BASIS AFTER THE VEHICLE HAS SAT FOR THE NIGHT. IT IS A SAFETY CONCERNS AS THE CAR WILL RANDOMLY STALL ON THE INTERSTATE DRIVING AT INTERSTATE SPEEDS. THE VEHICLE IS UNDER FORD'S EXTENDED WARRANTY, AND HAS BEEN TO (2) SEPARATE DEALERS TO TROUBLESHOOT. THE FIRST DEALER COULD NOT REPRODUCE THE ISSUE, THE DEALER IT IS CURRENTLY AT, HAS BEEN ABLE TO REPRODUCE THE ISSUE MULTIPLE TIMES, BUT NOT SURE THE ROOT OF THE PROBLEM, AS IT DOESN'T STORE ANY CODES. THE DEALER BELIEVES IT IS A HIGH SPEED CAN NETWORK MALFUNCTION. IT HAS BEEN IN THE REPAIR SHOP FOR A TOTAL OF 12 WEEKS. I HAVE VIDEO'S OF THE OCCURRENCES, AS WELL AS VOICE-MAILS FROM THE DEALERSHIP STATING THAT THEY CAN REPRODUCE THE FAILURE.

Feb 11, 2020

ENGINE,ENGINE AND ENGINE COOLING

5 complaints

The contact owns a 2017 Ford Explorer. The contact stated that the check engine warning light was illuminated on the instrument panel. The vehicle was initially taken to an independent mechanic to be diagnosed. The contact was informed that the coils and spark plugs were damaged and needed to be replaced. The vehicle was then taken to a dealer where a diagnostic was performed; the diagnostic test showed that coolant had leaked into cylinder #3. The manufacturer was notified of the failure but offered no assistance; the contact was referred to the NHTSA Hotline to file a complaint. The vehicle was not repaired. The failure mileage was 54,186.

Mar 11, 2024

Head gasket failure allowing coolant to leak into cylinder 1. Starts rough, but could result in lost of power or engine failure while driving. Ford dealer has confirmed the issue and said this shouldn't happen to a car with only 77,500 miles on it (2017 Ford Explorer XLT 4WD 2.3L Ecoboost 4 cyl. engine). Have to repair or replace engine depending upon the extend of damage.

Feb 28, 2024

I experienced the expulsion of coolant underneath the hood of my vehicle in the parking lot / driveways the past month or so. I took this into my mechanic and they diagnosed with water pump failure, need of timing chain assessment and 12 hours of expected labor. This issue has been recalled in Canada, but not here in the U.S. This is a significant amount of money to fix this and a safety issue as this vehicle is often driven in rural areas late at night. If inspection upon request is needed I can make it available.

Nov 20, 2023

The car started overheating while on my way home from a trip. I had to get a wrecker to haul it in. Ford offered no help. It was the water pump. Milage at the time was 103,000, Cost to fix $3000. So no Thanksgiving for me this year.

Nov 16, 2023

Mechanic confirmed water pump failure. Explorer was brought to mechanic for issue with heater. Upon inspection by mechanic, the coolant was low. Mechanic filled the coolant and left the vehicle idling. Water was seen leaking from undercarriage. Vehicle cannot be safely driven until water pump is replaced. Minimum cost of $2000 to complete repair.

Oct 19, 2023

UNKNOWN OR OTHER,ENGINE,FUEL/PROPULSION SYSTEM

4 complaints

It is known that for the specific year make and model that the water pump goes out around 100,000 miles. This water pump was built as an internal water pump, which is not typical for most cars. in order to fix this part, the engine has to be taken out and lots of parts have to be disassembled Just to get to it. The part Itself is fairly cheap, but the labor cost thousands of dollars due to where it is located. Ford knowingly built this car and put that pump where it is at and therefore should be reliable to pay the cost when it is so common that this part goes out around 100,000 miles. if it is a known issue that occurs on these models frequently then it should become a recall because a failing water pump can cause significant issues within the engine and make the vehicle in operable.

Sep 22, 2025

I am submitting this complaint regarding a recurring turbocharger issue in my 2017 Ford Explorer Sport (VIN: [XXX] ). In April 2024, I was forced to replace the turbocharger system at a cost of approximately $2,500. Despite the repair, my vehicle continues to have serious performance issues. Most recently, the check engine light returned, and a diagnostic scan from O’Reilly Auto Parts showed error code P219A – Bank 1 Air/Fuel Ratio Imbalance. This code indicates that the engine is still not functioning correctly—pointing to a likely underlying or unresolved defect. During the initial failure, oil leaked extensively into the engine bay and burned off in thick white smoke while I was driving. It was a serious safety concern, and the cause was consistent with Ford’s existing recall for this engine (NHTSA Campaign Number: 16V925000), which was limited to the Police Interceptor Utility model despite the civilian Sport version using the same 3.5L EcoBoost V6 engine and components. It is extremely concerning that my vehicle—outside of the official recall range—suffered the same turbo failure and now continues to show problems even after a costly repair. Either the mechanic’s initial repair was incomplete, or the core design flaw that caused the issue in the first place is still at play, meaning this problem may continue to repeat itself. I respectfully request that: 1.Ford expand the recall to include vehicles with the same components and failures, regardless of their designation. 2.NHTSA investigate the scope of this issue across the broader 2017 Explorer Sport lineup. 3.Ford provide reimbursement or support for the costly repair, which has not resolved the issue. 4.Ford issue a technical service bulletin or revised part guidance if this is an ongoing engineering issue. I am happy to provide full documentation, photos, and service records if needed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

May 28, 2025

STRONG SULPHUR SMELL ENTERS CABIN WHEN ACCELERATING. NOT A ONE-TIME EVENT. *TR

Jun 25, 2020

I AM AN ATTORNEY FILING THIS REPORT ON BEHALF OF AND AT THE REQUEST OF MY CLIENT, THE VEHICLE'S OWNER. THE COMPLAINT IS A NOXIOUS ODOR WHICH FILLS THE VEHICLE DURING ITS OPERATION; AFTER NUMEROUS REPAIR ATTEMPTS BY FORD, THIS CONCERN HAS NOT BEEN CORRECTED. WHEN DRIVING THE VEHICLE, THE DRIVER HAS OBSERVED THE INTERIOR HAS BECOME INUNDATED WITH A NOXIOUS, OVERWHELMING, AND POTENTIALLY DANGEROUS ODOR OF GASOLINE, EXHAUST AND/OR FUMES. THE DRIVER HAS FELT ILL EFFECTS AFTER THIS OCCURRENCE AND IS CONCERNED ABOUT CARBON MONOXIDE POISONING OR OTHER HEALTH PROBLEMS AS A RESULT. THIS ISSUE IS VERY CONCERNING BECAUSE OF THE POTENTIAL HEALTH EFFECTS AND BECAUSE VEHICLE CANNOT BE DRIVEN FOR ANY SUBSTANTIAL PERIOD OF TIME WITHOUT FILLING WITH THIS ODOR. THE ISSUE HAS MOST OFTEN BEEN OBSERVED WITH HIGHWAY DRIVING WHEN THE ENGINE IS UNDER LOAD, I.E. ACCELERATING. THE PROBLEM HAS BEEN ONGOING SINCE SHORTLY AFTER THE TIME OF PURCHASE OF THE VEHICLE. THE FIRST REPAIR ATTEMPT BY THE DEALER FOR THIS SPECIFIC ISSUE WAS MADE IN JULY OF 2017. AT LEAST 4 REPAIR ATTEMPTS HAVE BEEN MADE SUBSEQUENTLY. THE ISSUE CONTINUES. THIS LAW FIRM HAS REQUESTED THAT FORD TAKE BACK THE VEHICLE AND REFUND THE CLIENT'S PURCHASE PRICE UNDER ARIZONA'S MOTOR VEHICLE WARRANTIES STATUTE.

Feb 28, 2018

ELECTRICAL SYSTEM,STRUCTURE

4 complaints

The contact owns a 2017 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure). However, the parts to do the recall repairs were not yet available. The contact stated that while driving at 80 MPH, the driver's side A-pillar trim detached from the vehicle. The local dealer was contacted. The vehicle was not repaired. Most recently, the keyless entry failed to function as intended. The local dealer was not contacted. The vehicle was not repaired after the most recent failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 85,000.

Aug 21, 2025

The contact owns a 2017 Ford Explorer. The contact stated that while driving 65 MPH, the vehicle made an abnormal beeping sound, the cabin lights illuminated unintendedly, and the message "Tailgate Ajar" was displayed. The contact decelerated and pulled over to the side of the road. The contact resumed driving; however, the failure persisted. The contact then became aware that the front driver's side door exterior keypad trim had detached and had fractured into two pieces, causing damage to the keypad wiring system. The vehicle was taken to the dealer, where it was determined that the keypad needed to be replaced. The contact purchased the part from the manufacturer's website, and the vehicle was taken to the dealer, where the part was installed; however, the failure recurred while driving. The dealer was contacted and provided an estimate for the repair. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 40,000.

Mar 31, 2025

The contact owns a 2017 Ford Explorer. The contact stated that while his wife was driving at an undisclosed speed, the front driver’s side door keypad fractured in half leaving the wires exposed. No warning lights were illuminated. The dealer was made aware of the failure but confirmed that the parts to fix the vehicle was not available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 135,000.

Jul 10, 2024

The contact owns a 2017 Ford Explorer. The contact stated while her husband was driving at an undisclosed speed, the "Liftgate Ajar" message was displayed. The contact's husband pulled over and inspected the trunk, and the trunk was properly closed. The contact's husband then became aware that while opening the front driver's side door, the keyless entry keypad had detached. The dealer was made aware of the failure; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was unknown.

Jul 10, 2024

STEERING,SUSPENSION

4 complaints

The contact owns a 2017 Ford Explorer. The contact stated while accelerating from a complete stop from a traffic light, the vehicle made an abnormally loud popping sound. The contact exited and inspected the vehicle but could not determine the cause of the failure. The contact stated that upon attempting to resume driving, the steering wheel was uncontrollable, the suspension seemed to have failed, and the vehicle was sliding. The message "Terrain Management System Fault" was displayed. The vehicle was taken back to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not notified of the failure. The failure mileage was approximately 45,000.

Aug 04, 2025

In March of 2022, this vehicle was repaired for a rear suspension toe link recall. On Christmas evening, December 25, 2022, the toe link failed. The car fishtailed briefly before veering uncontrollably off the road. I had no warnings that this was going to happen aside from a slight "clunk" in the rear of the car a second beforehand. Fortunately oncoming traffic immediately stopped and avoided me and I was able (with much difficulty) to move the car to safety. I was only going about 35 mph; I cannot imagine how much carnage I would have created had I been on the highway I was headed to just 3 miles away. The car was flat-bedded to the Ford dealership that has always repaired the car the very next morning, December 26. While waiting for the wrecker, I walked the area where I heard a "clunk" just before the car's steering became inoperable and found a bolt which I brought with me to the dealership. In conversations on December 27, 28 and 29, the Ford service manager stated to me that he and the shop foreman were at a loss as to why the rear suspension toe link failed, but in examining the bolts, they believe they were machined/bored just a little too small allowing it the ability to unscrew itself from the toe link assembly and fall off the car. While the car was at the dealership, I reached out to Ford Motor Company's customer escalation team with the issue. My concern was not just for my own safety, but there are 600,000 other Ford Explorers on the road that might experience the same failure. On Friday, one of the team's members called me back to say that her investigation revealed that the bolt simply unscrewed itself. When I asked "well don't you think this is a huge recall issue?" she stated that investigation/issuing safety recalls are not the job of Ford. When I asked if the bolt unscrewing itself seemed plausible, she responded "I don't know." I have not yet picked up the car though the dealer replaced both toe link assemblies. I am GRAVELY concerned.

Jan 01, 2023

HAVE A NOISE ON FRONT PASSENGER SIDE SUSPENSION

Sep 28, 2019

REAR SUSPENSION TOE LINK RECALL: DRIVING APPROXIMATELY 50 MILES/HR WITH MY HUSBAND BEHIND THE WHEEL AND MYSELF AND OUR 3 CHILDREN IN THIS FAMILY VEHICLE, THIS REAR SUSPENSION BROKE. WE LIVE IN RURAL SALINE COUNTY AND DRIVE GRAVEL DAILY. THE INCIDENT HAPPENED WHILE ENTERING A BRIDGE ON A HIGHWAY. WE LOST ALMOST COMPLETE CONTROL OF STEERING REQUIRING THE DRIVER TO COMPLETELY TURN THE WHEEL AS QUICKLY AS POSSIBLE IN ONE DIRECTION AND TURN BACK AS QUICKLY AS POSSIBLE IN THE OTHER SWERVING AND FORCEFULLY CIRCLING BACK AND FORTH ON A BRIDGE UNTIL THE VEHICLE FINALLY CAME TO A STOP FURTHER DOWN THE ROAD. GOD' GRACE ALONE SAVED US FROM GOING OVER THE BRIDGE, OR HITTING ONCOMING TRAFFIC OR HAVING INJURIES, POTENTIALLY FATAL AT THIS RATE OF SPEED AND LOCATION. I AM DISSATISFIED IN THE NOTIFICATION OF RECALL INFORMATION FROM THE DEALER AND NHTSA. I ONLY FOUND OUT WHAT MUST HAVE HAPPENED AFTER GOOGLING 'FORD EXPLORER' AND SEEING A NEWS POST 2 DAYS EARLIER. THE NOTIFICATION OF THE RECALL WILL COME MUCH TOO LATE IN THE MAIL IN THE NEXT COUPLE WEEKS. TOO LATE! THERE HAS GOT TO BE A BETTER, FAST WAY OF NOTIFYING DRIVER SO THE RECALL PARTS MORE TIMELY. WE HAVE THE TECHNOLOGY. PUT YOUR FAMILY IN THIS SITUATION AND SAY THIS WAY OF NOTIFYING THE CONSUMER IS ADEQUATE!

Jun 19, 2019

FUEL SYSTEM, GASOLINE

4 complaints

The contact owns a 2017 Ford Explorer. The contact stated that while driving 60 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The contact stated that the vehicle jerked and vibrated. In addition, the vehicle stalled. No warning lights were illuminated. The vehicle was able to partially coast to the side of the road. The vehicle failed to restart. The vehicle was towed to the dealer where it was diagnosed that the fuel pump had failed and needed to be replaced. The vehicle was repaired. The manufacturer was not made aware of the failure. The failure mileage was 94,084.

Jul 14, 2025

The contact owns a 2017 Ford Explorer. The contact stated that while the vehicle was receiving routine maintenance and an oil and filter change, it was discovered that coolant was leaking into the engine. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 88,762.

Jun 06, 2025

The contact owns a 2017 Ford Explorer. The contact stated that after refueling the vehicle, the fuel gauge displayed a full tank; however, the Distance To Empty indicator was incorrect. The vehicle was taken to an independent mechanic, who diagnosed that the fuel pump monitor needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 40,800.

Mar 22, 2024

DRIVING ON INTERSTATE AND SMELLED A STRONG ODOR AND FUMES. NO CARS OR TRUCKS WERE IN FRONT OF ME AND I COULD NOT FIGURE OUT WHERE THE ODOR WAS COMING FROM. LATER IN THE 3 HOUR DRIVE, GOT VERY SLEEPY AND DIZZY. STOPPED AT REST AREA FOR FRESH AIR. THIS HAS NEVER HAPPENED TO ME BEFORE. NOW AFRAID TO DRIVE THIS EXPENSIVE VEHICLE ON THESE TRIPS TO TAKE CARE OF GRANDCHILDREN. CALLED DEALERSHIP AND WAS TOLD NO RECALLS AND NOTHING THEY COULD DO. PURCHASED THIS VEHICLE FOR DRIVING LONG DISTANCES AND NOW AFRAID TO DRIVE IT AND MY SON WILL NOT LET OUR GRANDCHILDREN RIDE IN IT. CANNOT SALE IT BECAUSE I WOULD LOOSE SO MUCH MONEY. A RECALL SHOULD BE ISSUED SINCE NUMEROUS COMPLAINTS HAVE BEEN MADE FROM OTHERS WITH THE SAME ISSUES.

Oct 25, 2017

VEHICLE SPEED CONTROL

4 complaints

The car has a hard time with acceleration and I hear clunking noises

Feb 27, 2025

AUGUST 2020: WHEN PASSING A VEHICLE ON THE HIGHWAY, APPLIED GAS PEDAL FULLY TO THE FLOOR, IT STUCK. VEHICLE CONTINUED TO ACCELERATE, PEDAL WOULD NOT RETURN TO NORMAL POSITION. HAD TO GET TO SHOULDER, SHOVE VEHICLE INTO NEUTRAL AND TURN OFF. FORD DEALER REVIEWED, DETERMINED ONLY LIKELY CAUSE COULD BE THE THROTTLE BODY, REPLACED THROTTLE BODY. APRIL 2021: WHEN ACCELERATING ON THE HIGHWAY, PRESSED PEDAL TO FLOOR, PEDAL ONCE AGAIN STUCK. WOULD NOT RETURN TO NORMAL POSITION, CONTINUED TO ACCELERATE. MOVED TO SHOULDER AT HIGH RATE OF SPEED, APPLIED BRAKES AS MUCH AS POSSIBLE AND PUT VEHICLE INTO NEUTRAL, THEN PARK. VEHICLE COMPLETELY REVVED OUT, ENGINE AT MAX RPMS. TURNED OFF VEHICLE. WAITED A FEW MINUTES. TRIED TO TURN VEHICLE BACK ON, SOUNDED LIKE STARTER WAS STUCK. TURNED OFF VEHICLE. WAITED A FEW MOMENTS, TURNED ON AND DROVE CAREFULLY HOME.

Apr 07, 2021

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. WHILE DRIVING 65 MPH AND DEPRESSING THE ACCELERATOR PEDAL, THE VEHICLE DECELERATED TO 20 MPH. THE CONTACT WAS ABLE TO PARK ON THE SIDE OF THE ROAD. THERE WERE NO WARNING INDICATORS ILLUMINATED. CONTACT STATED CAR WOULD NOT PICK UP SPEED AND LOST POWER. THE VEHICLE WAS TAKEN TO HERTRICH FORD LINCOLN (LOCATED AT 1427 BAY RD, MILFORD, DE 19963, (302) 725-0031) AND INFORMED THEM OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 29,177. *BF

Sep 25, 2019

THREE DIFFERENT TIMES IN MOTION ON THE HIGHWAY SUDDEN ACCELERATION OCCURRED WHILE CRUISE CONTROL WAS ENGAGED OR WHILE BEGINNING TO START CRUISE CONTROL AT AN ACCESSIVE RATE OF SPEED.

Aug 10, 2018

ELECTRICAL SYSTEM,ENGINE

4 complaints

The contact owns a 2017 Ford Explorer. The contact stated that the vehicle was running rough and was shuddering while starting and driving. The check engine warning light was illuminated. The contact stated that the failure had been recurring. The vehicle was taken to an independent mechanic twice. The mechanic determined that rodents had damaged the wiring underneath the hood. The vehicle was repaired; however, the failure recurred. The vehicle was taken to the dealer several times, and the same assessment was made. The vehicle was repaired; however, the failure persisted. The dealer determined that the wiring underneath the hood and the wiring in the rear of the vehicle needed to be replaced due to rodent damage. The vehicle was being repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 52,877.

Apr 01, 2024

I took my Vehicle in because the AC stop blowing cold air, and the overheating lights kept coming on. After waiting for a week, I was told it was a water pump but that did not fixed the AC being at all, couple days later I got a call from the dealership (GRAPEVINE FORD) that the compressor went out. After 3 weeks of waiting, I end up paying out of pocket what is supposed to be covered based of this letter I received from FORD. I feel like I should not have to pay for something that FORD should have covered. Letter below explained the very issues I had with the vehicle, including OVERHEATING and damages like bad cooling relay would cause.

Sep 02, 2022

TL* THE CONTACT DRIVES A 2017 FORD EXPLORER POLICE VEHICLE. WHILE THE VEHICLE WAS STATIONARY, SMOKE APPEARED UNDER THE HOOD. THE VEHICLE WAS PUSHED OUT INTO AN OPEN PARKING LOT WHERE IT CAUGHT FIRE. PRIOR TO THE FIRE, THE CONTACT HEARD A LOUD NOISE. THE CONTACT STARTED TO EXTINGUISH THE FIRE UNTIL THE FIRE DEPARTMENT ARRIVED TO FINISH THE JOB. POLICE AND FIRE REPORTS WERE FILED. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO VILLAGE FORD (23535 MICHIGAN AVE, DEARBORN, MI 48124, (313) 565-3900) WHERE IT WAS CURRENTLY BEING INVESTIGATED. THE CONTACT THAT THE FUSE PANEL MAY HAVE MELTED AND CAUSED THE FIRE AFTER RESEARCHING OTHER VEHICLES OF THE SAME YEAR, MAKE, AND MODEL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 65,000. *LN*JB CONSUMER WAS TOLD THAT VEHICLE WAS A TOTAL LOSS. VEHICLE WAS SENT TO HIS COMPANY'S ATTORNEY FOR A POSSIBLE REPLACEMENT VEHICLE. *DL

Nov 18, 2019

Fire: 1

AFTER A STOP, THE CAR WAS AT STATIONARY, WAS NOT ABLE TO START THE CAR BY PUSHING THE START BUTTON, GAVE ME ERROR ON THE DASHBOARD "FULL ACCESSORY POWER ACTIVE". TRIED TO TURN IT OFF, AFTER MULTIPLE TIMES OF TRYING, WAS ABLE TO START THE CAR, IT HAS 606 MI ON IT.

Oct 17, 2016

ENGINE,FUEL/PROPULSION SYSTEM

4 complaints

The water pump went bad which cost me 1500 dollars and the shop whom done it had replaced 15 water pumps on the exact make and model car as mine this year!

Jul 27, 2023

What component or system failed or malfunctioned, and is it available for inspection upon request? I have been experiencing the smell of gas/exhaust leaking into the cabin. How was your safety or the safety of others put at risk? I am concern with the health issues that this smell could put my family and I in. Specially if theirs a possibility that carbon monoxide could be leaking into the cabin. Has the problem been reproduced or confirmed by a dealer or independent service center?No Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? I had the vehicle inspected by Ford but they advise that they couldn’t reproduce the smell. They also advice that their were a two drain plugs missing in the lift gate which would resolve the issue if replaced. I have replaced the two missing plugs and continue to experience the issue. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear?no

Jun 12, 2021

EXHAUST FUMES ENTERING VEHICLE WHEN STATIONARY AND IN MOTION.

Sep 12, 2017

AFTER A SCARY LONG DRIVE FROM INDIANA TO NORTH CAROLINA I TOOK MY VEHICLE TO THE LOCAL FORD DEALER SERVICE DEPARTMENT LETTING THEM KNOW THAT I COULD SMELL EXHAUST WHILE DRIVING AND I FELT OVERLY TIRED, WAY MORE TIRED THEN NEED BE. AFTER TESTING IT WAS DETERMINED THAT CO WAS COMING INTO THE CABIN OF MY VEHICLE. THEY STILL HAVE MY VEHICLE NOW AFTER 2 WEEKS AND THE PARTS THAT WERE ORDERED WERE BODY FILLER AND ELECTRICAL TAPE. THIS DOES NOT SEEM TO BE THE APPROPRIATE FIX FOR THIS SITUATION THAT COULD CAUSE CATASTROPHIC INJURY OR DEATH AND NOW I AM SCARED TO PUT MY AND MY FAMILIES LIVES IN DANGER DUE TO MY VEHICLE TRYING TO KILL US. THE VEHICLE WAS BEING DRIVEN ON THE INTERSTATE AS SPEEDS OF 50-75 MPH. THIS IS VERY DANGEROUS AND IF I WOULD NOT HAVE STOPPED SO MANY TIMES I WOULD HAVE PASSED OUT AND CAUSED AN ACCIDENT WHICH COULD HAVE KILLED ME OR SOMEONE ELSE. I WAS ADVISED THAT IF I WAS GOING TO DRIVE THE VEHICLE I SHOULD DO SO WITH THE WINDOWS DOWN, WHICH IS NOT ACCEPTABLE AND WHY I HAVE HAD A LOANER CAR FOR WEEKS.

Sep 01, 2017

UNKNOWN OR OTHER,VISIBILITY/WIPER

3 complaints

To whom it may concern, I am writing to formally file a complaint with ford. I request immediate assistance regarding multiple open recalls on my 2017 Ford Explorer Platinum. Despite multiple attempts to have these recalls addressed by my local Ford dealership and others, they have refused to perform all the necessary repairs. When I asked if they could at least order the required parts, I was informed that they would not, due to the parts being on back order with no timeline of when they would be available. This situation has become increasingly concerning, as one of the un repaired recalls has now led to water intrusion inside my vehicle, causing additional damage. Along with other recalls that are further causing damage. I depend on my vehicle daily, and the ongoing delays and lack of action from the dealership have only worsened the condition of my vehicle. At this point, I am requesting further help. I believe this situation warrants urgent attention, as it involves manufacturer-issued safety recalls that remain unresolved through no fault of my own, after various attempts to get these recalls fixed. I would appreciate a prompt response confirming that this case has been escalated to the appropriate department.

Oct 15, 2025

Exterior windshield A-pillar flew off on the highway and ford said the repair was suppose to be ready on the latter half of 2024. This repair is not being dealt with in a timely manor. Manufacturer Recall Number 24S0. NHTSA Recall Number24V031.

Oct 14, 2025

The trim around my windshield fell off while driving. I called a local ford store, Ed Martin Ford in Anderson, Indiana and was told the current recall does not cover this.

Feb 15, 2024

POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

3 complaints

intermittened starting problems, vechile wont start, clicks, then starts and power train light comes on. Waiting at a red light, press the gas and the car does not go, also when speeding up transmission slips.

Jul 31, 2025

Crash: 1

Vehicle’s coolant over temperature warning light comes on only on highway and vehicles slows, which can cause a crash. However, temp gauge fluctuates quickly going back and forth from normal to hot.

Jun 15, 2024

MY 2017 FORD EXPLORER XLT WITH BASE 3.5 V6 HAS BEEN HARD TO START FROM THE FIRST WEEK OF OWNERSHIP. IT HAS LESS THAN 5000 MILES ON IT NOW AND ISN'T FIXED. FORD DEALERSHIP STATED IT WOULD HAVE TO GET WORSE BEFORE THEY COULD FIX IT. VEHICLE SHOWS NO DTC'S OR ANY HISTORY! MY WIFE HAS REFUSED TO DRIVE IT OUT OF TOWN DUE TO THE FEAR OF IT NOT STARTING AT ALL. WE HAVE RECORDED OVER 30 VIDEOS OF IT NOT STARTING AND HAVE SENT VIDEOS TO FORD MOTOR CO. WITH THE SAME RESPONSE, CANT FIX IT IF IT ISN'T BROKE. APPARENTLY IT WILL HAVE TO EITHER BREAK SOMETHING INTERNALLY AND LEAVE MY WIFE AND CHILD STRANDED, BEFORE IT WILL BE DIAGNOSED. IT IS A $40000 LEMON THAT TAKES 3-4 TIMES ATTEMPTING TO START BEFORE THE ENGINE WILL RUN. THIS WEEKEND IT TOOK AT LEAST 30-40 SECONDS BEFORE VEHICLE STARTED, THEN IT WOULD NOT IDLE CORRECTLY! STILL NO DTC'S! VEHICLE DOES THIS NO MATTER THE LENGTH OF TIME ENGINE HAS RUN OR LEVEL OF FUEL? IT DOES IT DURING REMOTE START OR THE PUSH BUTTON. IT DOES AT TIMES HAVE A STRONG ODOR OF GAS AFTER START-UP, ALMOST AS IF IT WAS FLOODED? AS A PERSON IN THE AUTOMOTIVE REPAIR WORLD, THE ABSENCE OF CONCERN FROM FORD IS SHOCKING! SO INSTEAD OF TRYING TO CORRECT A ISSUE BEFORE IT BECOMES A DANGER, THEY WOULD RATHER IT BECOME DANGEROUS AND THEN REPAIR IT? IF IT IS A FUEL RELATED ISSUE, THEN THIS IS A POTENTIAL HAZARD THAT NEEDS TO BE ADDRESSED. THE VEHICLE IS GETTING WORSE, BUT AS SAID EARLIER, IT WILL HAVE TO COMPLETELY NOT START BEFORE SOMETHING IS DONE. FORD MOTOR CO HAS NOT BEEN VERY HELPFUL, AND NOW I AM PROUD OWNER OF VEHICLE THAT WILL NOT START CORRECTLY.

Oct 23, 2017

LATCHES/LOCKS/LINKAGES

3 complaints

The contact owns a 2017 Ford Explorer. The contact stated the front passenger’s side door failed to open as intended. The contact stated that after several attempts using the key fob to unlock the door, the door failed to open. In addition, the code to unlock the door failed to work as intended. The contact's daughter manually locked and unlocked the door. The contact stated that when the door was opened manually, the panic alarm activated. The local dealer was contacted; however, the vehicle was not diagnosed or repaired due to the cost. The contact stated that the failure persisted. The contact stated that on a separate occasion, the rear driver's side door failed to open as intended. The vehicle was not diagnosed or repaired after the most recent failure. The manufacturer had been informed of the failure. The failure mileage was approximately 70,000.

Jun 27, 2025

The contact owns a 2017 Ford Explorer. The contact stated the rear driver’s side door failed to open as needed. The contact took the vehicle to the local dealer, where it was diagnosed with needing the rear driver’s side door latch to be replaced. The vehicle was repaired but the rear passenger’s side door latch experienced a similar failure. The contact took the vehicle to the local dealer, where it was diagnosed with needing the rear passenger’s side door latch to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 80,000.

Jun 21, 2023

The contact owns a 2017 Ford Explorer. The contact stated that the front and rear passenger's side doors failed to open from the outside whenever the door was locked. The dealer was notified of the failure and informed the contact that the failure was a known issue. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 79,000.

Dec 08, 2022

AIR BAGS,SEAT BELTS

3 complaints

The contact owns a 2017 Ford Explorer. The contact stated while driving at various speeds, the air bag warning light illuminated. The contact stated that the air bag warning light intermittently illuminated while driving at various speeds. The vehicle was taken to the dealer and was diagnosed with air bag light row #2 inflatable found on higher wire circuit installed, and the was fuse replaced. Additionally, row #2 buckle, rear center row passengers seat, rear driver seat would not buckle, and that the passenger seat buckle was internally fractured, and the buckle assembly needed to be replaced. The vehicle was not repaired. The dealer informed the contact that the parts were on backorder. The manufacturer was made aware of the failure. The failure mileage was approximately 104,000.

Feb 28, 2025

THE SECOND ROW SEATBELT AIRBAGS CONTINUE TO SET OFF THE AIRBAG SENSOR ON THE CONTROL PANEL AND FORD TECHNICIANS CAN FIND NOTHING TO CORRECT. SENSOR SET OFF WHILE DRIVING AND PASSENGER BELTED INTO DRIVER SIDE SECOND ROW SEAT BELT THAT CONTAINS A SEATBELT AIRBAG.

Apr 07, 2019

WITHIN THE FIRST 2 WEEKS OF GETTING MY VEHICLE THE AIRBAG LIGHT ON THE DASH WOULD COME ON AND OFF RANDOMLY WHILE DRIVING. RESTARTING THE CAR WOULD SOMETIMES FIX IT. TOOK IT TO THE DEALER TOOK 5 DAYS TO FIX IT. ENDED UP BEING THE DRIVERS SEAT BELT TENSIONER.

Mar 04, 2017

POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE

3 complaints

Transmission is not shifting correcting. Will be traveling down the road and loses power, loses it's acceleration. When trying to proceed after making a stop at a light, car will not go. Bucks hard when putting in reverse. I heard there was a recall on the torque converter's awhile back, but I never received any notification about it. Now that I know, the ford dealerships are telling me there are no recalls for this.

Jan 16, 2025

- Transmission/torque convertor has and is failing. Results in lack of acceleration during launch, sluggish vehicle operation and shudder - Known issue with this make/model/year of vehicle. Failure of the above began at 40,000 some miles and is presently not driveable at only 67,000 miles without an $8-$10,000 repair for a new transmission. - Confirmed with dealer the above issue and is in writing and submitted Case #CAS-47518676-K5Y6Y7 with Ford directly. Located letter sent to dealerships regarding this very issue dated 10/2020. - Vehicle has not been in any accidents, but am receiving a "warning" light indicating failure.

Mar 11, 2024

The transmission would slip and/or lag. This started around 65k miles. It was reported to the dealer, they couldn’t reproduce it. Then at 101k miles the engine started vibrating when in gear and idling. Motor mounts were replaced, but the problem persisted. Eventually got the entire transmission replaced.

Feb 01, 2023

STEERING,SUSPENSION,POWER TRAIN

3 complaints

The transmission stops switching gears after going 70 mph on the highway no acceleration was possible Just stopped working. I had my kids with me I had a tractor trailer behind me and in front of me and beside me on a very busy highway going 70 mph and the transmission just stopped working no gas was it was just redlining when it was supposed to be accelerating no gears were reached I had to throw it in park throw it back into sports mode they're back into drive they're back into sports mode they're back in the drive before it kicked in and would go all while in the middle of a busy highway and not able to get off the road and declining in speed. The manufacturer or Ford did purchase the vehicle from me and made me roll over my negative equity from that car into a new car was my only option or paying 10 grand to get it fixed. Nothing no lights were displayed no lights came on at all no warning signs nothing Just happened. When I took it in to get it looked at the mechanic immediately told me that I need to trade the car in and that I shouldn't have this vehicle it's transmission has been having multiple issues over four times in one year it was in the shop for transmission issues they told me nothing was wrong and they drove my car 200 mi they gave it back to me not even two weeks later this happened no lights and nothing was pulling on the codes The mechanic Harper from Malloy Ford is the one that told me that I should need to trade it in he contacted the Ford company they offered $2,000 to help with the cost to get the car fixed but it wasn't going to fix the problem from happening again and it was traumatizing to have to go through that with my kids I didn't want to put my kids back in that vehicle because we literally could have died. PLEASE REACH OUT WITH ANY ADDITIONAL QUESTIONS with my phone or email .. THE CAR HAS HAD TRANSMISSION ISSUES SINCE I BOUGHT IT.THE DEALERSHIP REFUSED TO TAKE THE CAR BACK AFTER I PURCHASED IT TO PUT ME IN SOMETHING ELSE

Dec 15, 2024

Vibration or rough idle in drive and reverse. Shudder while driving Lack of engine RPM Low performance, lack of acceleration on take off. Mechanic found and replaced the following. Broken Transmission Mount, Replaced Front & Rear Engine Mounts. Transmission is not shifting correctly and the Mechanic stated that the oil was black and smelt burnt.

Apr 12, 2023

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 65 MPH, THE STEERING WHEEL VIBRATE AND THE FRONT END OF THE VEHICLE SHOOK AND VIBRATED. THE TIRES WERE REPLACED AND ROTATED HOWEVER, THE FAILURE CONTINUED. ADDITIONALLY, WHILE SHIFTING GEARS, AN ABNORMAL BOOMING SOUND WAS COMING FROM THE TRANSMISSION. THE CONTACT INDICATED THAT THE FAILURE OCCURRED WHILE RELEASING OFF THE ACCELERATOR PEDAL. THE VEHICLE WAS TAKEN TO ORANGE PARK FORD LOCATED AT 7700 BLANDING BLVD, JACKSONVILLE, FL 32244 HOWEVER, THE FAILURES WERE NOT DUPLICATED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 40,000.

Oct 16, 2020

VISIBILITY,STRUCTURE

3 complaints

The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at approximately 70 MPH, the front driver’s side windshield trim detached from the vehicle. The contact took the vehicle to the dealer and the contact was informed that the trims and the windshield needed to be replaced. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The failure mileage was 100,000. VIN tool confirms parts not available.

Jun 11, 2024

The contact owns a 2017 Ford Explorer. The contact stated while driving approximately 70 MPH, the front passenger’s side window trim detached from the vehicle. The vehicle was taken to the dealer and the trim was replaced. The contact stated while driving approximately 60 MPH, the front driver’s side trim detached. The failure caused the trunk button to open and close the trunk. The message trunk latch ajar was displayed on the instrument panel. The vehicle had not been taken to the dealer to be diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 75,000.

Sep 20, 2023

The contact owns a 2017 Ford Explorer. The contact stated that the front side of the roof connected to the upper center of the windshield was severely corroded. The dealer was notified of the failure and informed the contact that they could not assist unless the part was perforated. The contact stated that as the roof became perforated, the vehicle was taken back to the dealer where it was diagnosed that the roof and the windshield needed to be replaced. The dealer sent a diagnostic report with pictures to the manufacturer. The manufacturer advised that they would cover the repair of the vehicle. The vehicle was not repaired. The failure mileage was approximately 67,000.

Apr 06, 2022

EXTERIOR LIGHTING

3 complaints

Headlight went out due to water intrusion on plug and module.

Jun 05, 2024

The low beam LED light has gone out which consists of replacing the whole headlight assembly. The dealership wants $2000 to replace this unit. Looking online at car forums this is a known issue on these explorers. Our explorer is from 2017 with only 31000 miles on it which means at most the headlight has been on for only 516 hours. LED lights should be lasting for 30000-40000 hours. This is a safety concern as driving without a low beam headlight is a concern to the person driving as well as any other person on the road. The vehicle issue has been confirmed and inspected by the dealer and there were no symptoms or messages of the problem prior to it occurring. Ford should be liable to repair the headlight in these instances as their product is a safety risk and malfunction on their end.

Jun 20, 2022

THE HEADLIGHTS ARE FAR TOO BRIGHT,EVEN IN DAYLIGHT CONDITIONS.AS AN UNINTENDED CONSEQUENCE OF AN EFFORT TO INCREASE THE VISIBILITY OF THE VEHICLE,THEY ARE QUITE CAPABLE OF MOMENTARILY BLINDING ONCOMING DRIVERS.OBVIOUSLY,THIS EFFORT TO INCREASE HEADLIGHT INTENSITY IS OVERLOOKING THE FACT THAT IT MAY BE CAUSING SERIOUS INJURY TO OTHER DRIVERS.

Jul 21, 2017

STEERING,SUSPENSION,WHEELS

3 complaints

Thr manufacturer did not put rear tire links on my vehicle. I purchased brand new tires 3 months ago and my two rear tires are already showing sings of wear and tear. I went to a mechanic to see if I could get a full alignment on my vehicle. When they started on thr alignment, they informed me that they could not proceed because the vehicle was missing the manufacturer rear toe links. If I decided to let them order rear toe links and do the alignment, it would cost me almost $600. This is completely unacceptable for ford to drop the ball again and we the consumer are stuck paying for something that they should.

Sep 10, 2023

I bought the SUV Used in January/2023 from a Ford dealer. It had brand new tires on it. 6 months later and the outer tread of the tires are bald, that’s when I realized the toe angle was pointed in. I went to Discount Tire to get new tires and an alignment. They put new tires on and then they told me they couldn’t do the alignment on my truck because it has a recalled part on the rear suspension. The toe angle rods are not adjustable. He showed me what they are supposed to look like on his computer for him to do the alignment. He then proceeded to tell me how dangerous it was because if the rod cracks, my wheel will fall off. I called ford, but they are claiming there is no recall for that part, but that can’t be true.

Aug 10, 2023

Tow links from my vehicle is going bad. Vehicle fish tails a little on the highway when traveling on uneven surface. Knuckles have been replaced and Link-Stabilizer on both side by my mechanic. Ford STATED they replaced in May 2022 (never did) I had the original parts that came with vehicle. Ford refuses to reimburse. I'm concern now that the tow links are going bad and vehicle will soon be unsafe to drive.

Apr 20, 2023

POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM

3 complaints

Both turbos failed and so did the water pump. Less than 90,000 miles. When the turbos failed, there was smoke from the tailpipes. Then there was noise under the hood. When the water pump failed, there was water leaking under the vehicle. Yes, the problem was diagnosed and fixed by the Ford dealership. One of the turbos was fixed last year. The water pump was fixed in December. The other turbo is waiting to be fixed because Ford changed the part due to manufacturing issues and we are currently going on 3 months without a vehicle. The turbos or water pump failure would have been a catastrophic engine failure at some point. Apparently this is a known issue with the 3.5L EcoBoost engines, but Ford has not issued a recall. Fortunately I have a Blue Oval Certified warranty on my Explorer, so the repair is covered. There were no lamps or warning lights during the part failures. I did not let the car overheat when the water pump was failing.

Mar 21, 2023

RE: 2017 FORD EXPLORER. CAR DYING OUT ON ACCELERATION FROM A STOP. A SCARY THING HAPPENED ON RT #619 TODAY IN HARTVILLE. THAT IS, THE CAR DIED OUT HALFWAY OUT ONTO THE ROADWAY, IT PAUSES FOR SOME SECONDS WHERE THE ACCELERATOR DOES NOTHING. THEN IT PICKS UP BY ITSELF. THE THROTTLE DOES NOTHING. NONE OF THESE ACTIONS ARE DESIRABLE. THESE BEHAVIORS PUT US IN GREAT DANGER. SO LET'S SEE, THIS HAPPENED TWICE IN THE MORNING I BROUGHT IT TO THE DEALERSHIP (MONDAY 01-06-2020). AND, IT HAPPENED ONCE THE 2ND DAY BACK TO ME ON FRIDAY 01-31-2019. BUT IT DID NOT HAPPEN FOR YOU IN THE 4 WEEKS YOU HAD IT TO TEST. AMAZING ISN'T IT? WELL, I THINK I'M GOING TO GO ALONG WITH THE MANY OTHER PEOPLE ONLINE THAT REPORT THE IDENTICAL PROBLEM THAT I EXPERIENCE. IN MY CAR, IT'S BEEN A PROBLEM SINCE NEW. I DO BELIEVE FORD IS WELL AWARE OF THIS PROBLEM. I ALSO BELIEVE THEY'RE NOT GOING TO DO ANYTHING TO CORRECT IT UNTIL THEY'RE MADE TO. WHEN I ASKED THE SERVICE MANAGER, HE SAID TO ME: "FORD TOLD US NOT TO DO ANYTHING UNLESS YOU CAN VERIFY IT." SO, YOU JUST DON'T VERIFY IT. IN "FORD THINK" THIS MUST MEAN THE PROBLEM DOESN'T EXIST. THIS PUTS ME IN MIND OF SOME YEARS BACK WHEN CARS WERE TAKING OFF BY THEMSELVES. PINNING, INJURING, AND EVEN KILLING SOME OWNERS. IT'S ODD, BUT IT WAS THE SAME THING BACK THEN. IT'S THE DRIVERS, THEY'RE DOING SOMETHING WRONG. IT'S NOT OUR CARS, AND THAT'S EXACTLY WHAT I'M BEING TOLD NOW. IT'S MY DRIVING HABITS. THE SAME HABITS THAT DON'T EFFECT MY OTHER 5 CARS. I DID NOT BELIEVE IT THEN, NOR DO I BELIEVE IT NOW. FORD SEEMS TO HAVE AN ODD MINDSET. TO FIND SOMETHING, YOU HAVE TO BE LOOKING FOR IT. AND, I ALSO REPORTED TO YOU THAT THE SYNC SYSTEM WAS GOING CRAZY, MAKING ADJUSTMENTS THAT WEREN'T NEEDED OR CALLED FOR. IT HAS TO BE CONTINUALLY READJUSTED. DID IT NOT DO THAT EITHER? IT DID IT FOR ME THE MINUTE I STARTED IT UP. THANK YOU, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Feb 01, 2020

VEHICLE STALLS WHEN DRIVING AND IS MORE PRONOUNCED WHEN MAKING TURNS. AFTER STALLING IT STARTS BUCKING AND I HAVE TO PRESS GAS PEDAL TO THE FLOOR TO GET A RESPONSE.

Aug 22, 2018

POWER TRAIN,SERVICE BRAKES,ENGINE

3 complaints

WHEN BACKING UP AND THE WHEEL IS TURNED THERE'S A HESITATION THEN WHAT FEELS LIKE I HIT SOMETHING. (A CLUNK W/O THE NOISE ) THEN WHEN BREAK PEDDLE IS PRESSED THE CAR SHIMMIES BAD . I ALSO SMELL ANTIFREEZE COMING FROM THE HEATER VENTS .BROUGHT IT BACK TO DEALERSHIP FOR THEM TO FIX IT SINCE IT WAS JUST PURCHASED THERE .. THEY HAD IT FOR 5 DAYS .. NOTHING GOT FIXED. THEY TURNED FRONT ROTORS AND TOPPED OFF FLUIDS. I DO BELIEVE THAT I HAVE A BAD REAR TOW BEARING OR A U-JOINT. BREAKS NOT SURE BUT THE CAR IS WORSE THAN BEFORE. STILL SMELL ANTIFREEZE AND THERE'S A DARK FILM ON THE WINDSHIELD WHICH INDICATES A BAD HEATER CORE. I'VE BROUGHT THIS TO THE ATTENTION OF THE DEALERSHIP BIT THEY WON'T RETURN MY CALLS OR EMAILS OR TEXTS. I BELIEVE I WAS SOLD A LEMON. THERE'S AN OXIDATION ON THE ENGINE AND A BLACK STAIN ON BOTTOM OF ENGINE. ALSO THE EXHAUST MANIFOLDS HAVE BEEN REPLACED. THIS IS A 2017 AND SHOULDN'T HAVE THIS MANY ISSUES .

Oct 17, 2020

WHEN BACKING UP THE VEHICLE WILL HESITATE THEN IT FEELS LIKE I HIT SOMETHING. THEN THERE'S A CLUNK .. (REAR TOW BEARING/U-JOINT) #2 HAVE TO ALWAYS HAVE DEFROST ON OR WINDOWS FOG UP.. THEN THERE'S A SMELL OF ANTIFREEZE COMING THROUGH THE VENTS. BREAKS GRIND WHEN STOPPING. REAR BRAKES AND ROTORS WERE REPLACED BY DEALERSHIP.. BREAK FLUID LOW, ALONG WITH A BUNCH OF OTHER ISSUES TRANSMISSION SLIPS WHEN TAKING OFF FROM A STOP. ALWAYS HAVE TO RESET AVERAGE GAS MILEAGE TO GET A READING. I BELIEVE I WAS SOLD A LEMON AS THE FINANCE GUY TOOK MY DOWN PAYMENT AND PURCHASED A EXTENDED WARRANTY WHICH I NEVER AGREED TO.

Sep 13, 2020

WHEN GEAR IS ENGAGED IN 'D' WITH ENGINE ON, VEHICLE MOVES WITHOUT FOOT ON THROTTLE. WHEN BRAKE IS APPLIED TO STOP IT, THERE COMES A LOUD VIBRATION FROM THE ENGINE WHICH BECOMES NERVOUS AND TRIES TO DRAG VEHICLE FORWARD UNLESS GEAR IS PUT IN 'N' OR 'P'. IT HAPPENS ANYTIME VEHICLE IS STATIONARY WITH ENGINE RUNNING INCLUDING STOP SIGNS AND TRAFFIC LIGHTS. NO CHECK LIGHT ON DASHBOARD. PHENOMENON OBSERVED IN EARLY FEBRUARY 2019.

Feb 24, 2019

UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM

3 complaints

TAKATA RECAL MY EXPLORER CAB IS FILLING WITH EXHAUST FUMES. MAKES ME DIZZY LIGHT HEADED AND NAUSEOUS PAYING FOR A VEHICLE I CAN'T EVEN DRIVE.

Oct 27, 2018

THERE WAS A COOLANT LEAK INTO THE HEATER BOX WHICH CAUSE THE HEATER CORE TO FAIL AND THEN IT BEGAN FILLING THE DRIVER'S SIDE OF THE CABIN WITH COOLANT FUMES FOR TWO MONTHS. THE VEHICLE SHOULD HAVE NEVER LEFT COURTESY FORD HERE IN PORTLAND OR. IT WENT BACK THREE TIMES FOR THIS ISSUE. IF THEY WOULD HAVE CONTACTED FORD MOTORS THEY COULD AND HAD THE KNOWLEDGE OF THIS MAJOR FAILURE HAPPENING. BREATHING IN COOLANT AND BEING TOLD IT'S OKAY. IT ISN'T IS IT? PLEASE HELP.

Jun 15, 2018

Injuries: 1

2017 FORD EXPLORER SPORT-WHEN MY CAR IS IN ACCELERATION THERE'S AN EXHAUST SMELL THAT CONSUMES THE CABIN. THIS HAPPENS EVERY TIME .

Nov 16, 2016

STRUCTURE,ENGINE

3 complaints

MY WIFE WAS INVOLVED IN AN ACCIDENT ON ICY ROADS ON DECEMBER 5. SHE WAS DRIVING OUR 2017 FORD EXPLORER WHICH WE HAD PURCHASED ON MAY 31, 2017. SHE WAS STOPPED AT A RED LIGHT ON A COUNTRY HIGHWAY AND HEADED NORTH. THE LIGHT TURNED GREEN AND SHE HAD JUST GOTTEN THROUGH THE INTERSECTION WHEN A VEHICLE THAT WAS HEADING SOUTH, LOST CONTROL AND HIT HER HEAD-ON. THE ATTACHED PICTURE SHOWS THE AMOUNT OF DAMAGE SUSTAINED ON THE FRONT END OF THE VEHICLE. BEYOND THIS DAMAGE, THE IMPACT WAS STRONG ENOUGH THAT A MOTOR MOUNT MOUNTING PIN WAS SHEARED CLEAN OFF THE MOTOR AS WAS THE COVER ON THE TIMING BELT. THE REBAR IN FRONT OF THE RADIATOR WAS SNAPPED COMPLETELY IN HALF. ALL THIS DAMAGE...AND THE AND AIRBAGS DID NOT DEPLOY. THERE WAS SUFFICIENT DAMAGE THAT THIS $50,000+ VEHICLE WAS CONSIDERED A TOTAL LOSS. I'VE CONTACTED THE FORD DEALERSHIP IN SIOUX FALLS, SD WHERE WE BOUGHT THE VEHICLE. AS SOON AS I MENTIONED AIRBAGS, THEY SAID THEY WOULD NOT ADDRESS OR COMMENT ON ANY ADDITIONAL QUESTIONS I RAISED ABOUT THE VEHICLE SAFETY FEATURES. I'VE CONTACTED FORD MOTOR COMPANY DIRECT. SAME STORY. AS SOON AS THE SUBJECT OF AIRBAGS WAS LOCKED FIRMLY IN THE MIND OF THE LADY I WAS TALKING WITH, SHE PROCEEDED WITH ABOUT TEN MINUTES OF QUESTIONS. AFTER SPENDING PROBABLY 20 MINUTES ON THE PHONE WITH THIS LADY, ALL I GOT WAS, "YOU NOW HAVE A CASE NUMBER IN OUR SYSTEM." WHEN I ASKED ABOUT GETTING ANY FOLLOWUP CORRESPONDENCE, I WAS TOLD, "ALL FUTURE CORRESPONDENCE WILL BE BETWEEN THE INSURANCE COMPANY AND FORD MOTOR COMPANY." AND, I'VE HEARD NOTHING SINCE. BECAUSE MY WIFE WAS NOT AT FAULT IN THIS ACCIDENT, WE ARE DEALING WITH THE OTHER DRIVER'S INSURANCE COMPANY (FARM BUREAU) AND GETTING TREATED LIKE WE WERE THE PERPETRATORS INSTEAD OF THE VICTIMS.

Jan 11, 2018

Crash: 1

Injuries: 1

CARBON MONOXIDE DETECTED IN PASSENGER CABIN - AFTER READING STORIES ABOUT POSSIBLE PROBLEMS WITH CARBON MONOXIDE (CO) IN 2016 FORD EXPLORERS IN MID JULY 2017 I PURCHASED A KIDDE BATTERY POWERED CO DETECTOR AND INSTALLED IT IN THE REAR AREA OF THE PASSENGER COMPARTMENT. IT HAD NOT ALARMED UNTIL WE WERE TRAVELING FROM SENECA, SC TO INDIANAPOLIS, IN. WE WERE TOWING AN 8X5 ENCLOSED U-HAUL TRAILER AT NORMAL FREEWAY SPEEDS. TOW/HAUL WAS ENGAGED BECAUSE WE WERE TOWING AND THE ENGINE WAS GENERALLY RUNNING AT HIGHER RPM'S, ESPECIALLY GOING UP THE MOUNTAIN INCLINES. THE CO DETECTOR FIRST ALARMED WEST OF ASHVIILLE, NC. SUDDENLY THE HEADACHES AND DROWSINESS BOTH MY WIFE AND I WERE EXPERIENCING MADE SENSE. WE OPENED THE WINDOWS AND THE ALARM STOPPED AFTER A COUPLE MINUTES. AFTER THIS HAPPENED 3-4 TIMES I MOVED THE DETECTOR TO THE FRONT OF THE PASSENGER CABIN SO THAT I COULD MONITOR THE PART PER MILLION DISPLAY. WE FOUND THAT IT ONLY TOOK 15-20 MINUTES OF HIGHWAY DRIVING FOR THE DETECTOR TO DISPLAY 31PPM, THE DETECTORS MINIMUM CONCENTRATION DETECTION THRESHOLD. THE LEVEL WOULD THEN BUILD OVER TIME. DUE TO THE DETRIMENTAL EFFECTS OF CO ON THE HUMAN BODY I NEVER LET THE CONCENTRATION EXCEED 62PPM. I FOUND, HOWEVER, THAT THE PEAK CO CONCENTRATION DETECTED WAS 103PPM. I ASSUME THIS WAS REACHED WHILE THE DETECTOR WAS IN THE REAR OF THE CABIN, WHERE THE DISPLAY WAS NOT VISIBLE TO ME. THE SERVICE MANAGER AT LAKE KEOWEE FORD SUGGESTED THAT I RUN THE HVAC IN RECIRCULATE MODE. I TRIED MANY DIFFERENT HVAC MODES - RECIRCULATE, NORMAL/OUTSIDE AIR, REAR HVAC TURNED OFF - BUT THE RESULT WAS ALWAYS THE SAME, CO BEING DETECTED IN THE CABIN WITHIN 15-20 MINUTES. NEEDLESS TO SAY I AM NOT BUYING FORD'S CLAIM THAT THIS PROBLEM IS ONLY WITH LAW ENFORCEMENT VEHICLES WITH BODY PERFORATIONS FROM THE INSTALLATION OF AFTER MARKET EQUIPMENT. THE VEHICLE IS GOING INTO A CARMEL, IN FORD DEALER THIS AFTERNOON.

Aug 16, 2017

OCCASIONALLY WHEN I DROVE THE CAR I FELT LIGHT HEADEDNESS AND DIZINIESS. ON 8/3/2017 I FELT THE DIZZINESS AGAIN AND ENDED UP IN A CAR ACCIDENT. I FELT AS THOUGH I WAS GOING TO PASS OUT AND IN A FLASH I CRASHED INTO THE CAR IN FRONT OF ME.

Aug 04, 2017

Crash: 1

ENGINE AND ENGINE COOLING,POWER TRAIN

2 complaints

The contact owns a 2017 Ford Explorer. The contact stated that while starting the vehicle, there was an abnormal sound coming from the engine. In addition, while driving at undisclosed speeds, there was an abnormal sound coming from the vehicle. The check engine warning light was illuminated. The contact stated that on a separate occasion, while driving 40 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal, and the vehicle jerked before slamming into gear. The check engine warning light was continuously illuminated. Additionally, the vehicle was leaking oil onto the ground and the engine was consuming an excessive amount of engine oil. The vehicle was taken to an independent mechanic who diagnosed the vehicle with coolant intrusion into a cylinder, which caused the engine failure. The spark plugs were replaced. The mechanic also informed the contact that the transmission had failed. The contact stated that the failure persisted. The manufacturer was made aware of the failure and referred contact to the NHTSA Hotline to report the failure. The failure mileage was 52,590.

Jul 28, 2025

The contact owns a 2017 Ford Explorer. The contact stated that while driving at various speeds, the vehicle was jerking, vibrating, and transmission was slipping. The vehicle was taken to an independent mechanic who diagnosed that the torque arm, engine mount, axle shaft, and catalytic converter were all damaged due to the jerking and vibrations from the vehicle. The vehicle was repaired. The vehicle was later taken to the local dealer who performed service repairs under an unknown Customer Satisfaction Campaign however, the failure persisted. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 46,000.

Sep 15, 2023

ELECTRICAL SYSTEM,SEATS

2 complaints

The contact owns a 2017 Ford Explorer. The contact stated that while seated in the parked vehicle, the rear passenger’s side head restraint became unhinged. The contact stated that the exterior front driver’s side pin paddle had failed. The vehicle was not taken to a dealer to be diagnosed. The contact stated that the railings on the rear passenger’s side seats were replaced, and the vehicle was repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 99,208.

Jul 02, 2025

The driver side heated seat does not work at all the passenger side heated seat works just the driver side does not work

Mar 30, 2024

WHEELS,UNKNOWN OR OTHER

2 complaints

Rear toe links, rear alignment is off. Dealership said they can’t fix it. My tires are wearing incredibly fast.

Nov 26, 2024

PURCHASED 2017 FORD EXPLORER DECEMBER 2017 WITH ORIGINAL HANKOOK VENTUS S1 NOBLE2 255/50R20 105H TIRES. HAVE 17,000 MILES AND HAVE BEEN ROTATED AT EACH OIL CHANGE; BEEN HAVING EXTREME TREADWEAR AND WAS TOLD BY THE AUTHORIZED DEALER THAT ITHE TIRES ARE BAD AND NEED REPLACED. DEALER SUGGESTED TO CONTACT HANKOOK DIRECTLY BECAUSE OTHERS HAVE EXPERIENCED SIMILAR ISSUES. I CONTACTED HANKOOK CUSTOMER SERVICE AND WAS TOLD THAT THE TIRES ARE BAD BUT THEY HAVE TO BE 4/32 TO GET A PRO RATED DISCOUNT, AT THIS TIME I HAVE 1-3/32, 2- 4/32 AND 1- 5/32, THE FORD DEALER WOULD NOT HONOR THE NEW CAR WARRANTY BECAUSE THEY SAID IT ISN'T A SAFETY ISSUE AND HANKOOK NEEDS TO TAKE CARE OF IT. MEANWHILE, NO ONE WANTS TO TAKE FULL RESPONSIBILITY FOR THESE BAD TIRES AT ONLY 17000 MILES, EVEN THOUGH THE EXPLORER IS RATED ON TOP FOR ROLLOVERS WITH A BLOWOUT... THIS IS ANOTHER DANGEROUS ISSUE SIMILAR TO THE FIRESTONE DISASTER. ARE THEY GOING TO WAIT UNTIL THERE ARE DEATHS BEFORE THEY START REPLACING THESE DEFECTIVE TIRES?

Oct 08, 2019

ELECTRICAL SYSTEM,LATCHES/LOCKS/LINKAGES

2 complaints

The contact owns a 2017 Ford Explorer. The contact stated that while driving at 80 MPH, the contact heard a loud bang, and the "Door Ajar" message was displayed. The contact pulled over and noticed that the front driver's side keyless entry keypad had detached, exposing the wires from the door. The contact drove to her destination, but the rear liftgate failed to open as needed and the interior lights failed to turn off. The contact purchased and replaced the 10-amp fuse under the steering wheel, which resolved the failure with the rear liftgate and the interior lights; however, the front driver's side keyless entry keypad was not repaired. The dealer was made aware of the failure; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 80,000.

Jun 24, 2024

The contact owns a 2017 Ford Explorer. The contact stated while driving approximately 55 MPH, the front driver’s side the keypad on the door detached from the vehicle and was hanging on by a wire. The contact stated that the liftgate ajar warning light was illuminated however, she was unable to open the liftgate. The contact took the vehicle to the local dealer and the dealer was made aware of the failure. The contact also requested that the vehicle be serviced and the recalls associated with the VIN be repaired. The vehicle was not diagnosed or repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 112,000.

Feb 15, 2022

AIR BAGS,UNKNOWN OR OTHER,SERVICE BRAKES

2 complaints

This is the second time again 15 minutes that I've had to continue to put in these complaints about the recalls it is you know everything else about not being notified about all the recalls which I think there are between 10 and 12 all the way from the rear towing to the a pillars to the headlight all the way down to the Cadillac converter cam trimming assembly etc not been notified one time bye anyone nothing George Coleman Ford dealership. Very unprofessional and I'm very [XXX] right now I've spoke LOL let the message for James Farley CEO of Ford and I will be letting him know everything that has been going on because of the a pillars of water has been able to get inside the vehicle because that is the rubber around the front windshield which is supposed to have been you know done accurately and which it wasn't because if it was there wouldn't be a recall but I'm getting [XXX] to have to find out all these recalls on my own and for the Ford dealership where I bought the vehicle has not tried to reach out whatsoever even about the roof rack recall they have the parts in but they had not notified me so therefore if anything happens during the for the headlight if I get a ticket y'all will be held responsible if I get into a bad car wreck y'all will be held responsible because of the rear toe link that's a very important part because it will make you crash into a ditch and die and yeah I'm just I'm [XXX] right now I can't wait for James Farley to call me back because he's going to he's going to find out how [XXX] I am and I'll go above the CEO and talk to the Ford family about these issues along with leaving bad reviews and y'all get deducted for every complaint. There's one person at George Coleman Ford that I would like to extend my gratitude towards and I don't know his first name his name is Mr Shockley that is a great man he's been the most helpful and he has went above and beyond to help me and my wife when I did ask him about the INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Jun 22, 2024

VEHICLE WAS TRAVELING APPROXIMATELY 40-50MPH ON THE HIGHWAY, TRAFFIC STOPPED ABRUPTLY, COLLISION WARNING SYSTEM WITH BRAKE SUPPORT DID NOT ACTIVATE, DRIVER ATTEMPTED TO MAKE A HARD STOP, BRAKES ENGAGED AT INITIAL PUSH OF THE PEDAL THEN BECAME UNRESPONSIVE REGARDLESS OF FORCE APPLIED TO THE PEDAL, VEHICLE REAR-END ANOTHER VEHICLE, AIR-BAGS DID NOT DEPLOY, SOS POST-CRASH ALERT SYSTEM DID NOT ACTIVATE, 911 ASSIST DID NOT ACTIVATE.

Jul 09, 2018

Crash: 1

BACK OVER PREVENTION

2 complaints

The contact owns a 2017 Ford Explorer. The contact stated that upon shifting the vehicle into reverse, he became aware that the center screen failed to display a rearview, potentially compromising the back-over prevention system. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the APIM. The vehicle was repaired. The manufacturer was notified of the failure but did not assist. The failure mileage was 140,000.

Mar 20, 2024

in 2019 with 55,000 miles on my 2017 Ford Explorer limited the screen which displays the front and rear cameras stopped working. after taking in for repair we had to replace the APIM module. then last week our 2018 Ford fusion with 35,000 miles had the same part fail. upon further research it appears that there are alot of Fords that have had the same problem. I'm filing this complaint because I believe Ford should be held responsible for making faulty parts.

Mar 18, 2024

ELECTRICAL SYSTEM,AIR BAGS

2 complaints

Air bag light came on the dash board Headed to dealer to see why Code B141C Cost to repair the problem was very high not covered by warranty The problem seems to me a poor design. Because of this weak design I feel this puts passengers in danger.

Mar 05, 2024

CAR PULLED IN MY LANE MY CAR AUTO BREAKED, I ALSO PUT ON BREAK THEN ICON CAME ON ABOUT AIRBAG ISSUE. TOOK TO FORD RUN TEST. THE PIG TAIL THAT GOES TO AIRBAGS, NEED TO SAUTER 21 PINS THAT GOES TO CONNECTION OF PIGTAIL TO AIRBAG.

Dec 20, 2020

ENGINE AND ENGINE COOLING,STRUCTURE

2 complaints

The contact owns a 2017 Ford Explorer. The contact stated that the exterior trims on the front passenger's side and the front driver's side windows were detaching. Additionally, the contact stated that while his wife was driving 75 MPH, the vehicle started shuddering and lost motive power. The contact's wife veered to the side of the road. The check engine warning light was illuminated. The contact stated that his wife was able to restart the vehicle and drove to the nearby residence. The vehicle was taken to the dealer, where it was diagnosed that the water pump had failed, and the front engine mount had collapsed. The dealer determined that the water pump needed to be replaced and the front engine mount needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 77,000.

Mar 01, 2024

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. WHILE THE VEHICLE WAS STATIONARY AND WHILE DRIVING VARIOUS HIGH SPEEDS, EXHAUST FUMES ENTERED INTO THE CABIN OF THE VEHICLE. WHEN THE HEATER AND AIR CONDITIONER WERE ACTIVATED, THE ODOR OF EXHAUST FUMES ENTERED THROUGH THE VENTILATION SYSTEM. THE CONTACT SUFFERED HEADACHES FROM EXPOSURE TO THE FUMES. CRAIN FORD IN LITTLE ROCK, ARKANSAS, 72210 REPLACED A GASKET AND SEALED THE VEHICLE (EXACT REPAIRS UNKNOWN), BUT THE FAILURE RECURRED. THE DEALER REFERRED THE CONTACT TO THE MANUFACTURER. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND PROVIDED THE CONTACT WITH CASE NUMBER: CAS-13337847. THE FAILURE MILEAGE WAS APPROXIMATELY 9,000.

Oct 18, 2017

SUSPENSION,AIR BAGS

2 complaints

Before the safety recalls for the rear suspension the vehicle made a loud noise almost like helicopter blades from the rear. It stopped after the recall was fixed but has started again. The air bag light has been on since about a month after I bought the vehicle. After about 9 attempts of taking it to the ford dealership for them to look at it with no luck I believe it’s due to a broken seatbelt in the rear that nobody has a part for.

Jun 17, 2023

THE REAR SUSPENSION STARTED WITH A LOWER NOISE IN THE REAR PASSENGER SIDE, WHENEVER I MAKE TURNS OR THE ROAD IS A LITTLE ROUGH. TO THIS DAY IS GETTING A LOT WORSE, MORE NOISE AND UNSTABLE WHEN I TAKE TURNS. ALSO THE SEAT BELT LIGHT COME ON, AND I WAS TOLD THAT THE MODULE IS MALFUNCTION AND NEED TO RESET OR REPLACE WITH A NEW ONE.

Apr 13, 2021

UNKNOWN OR OTHER,VISIBILITY

2 complaints

While driving on the freeway the passenger side windshield side panel flew off the car completely. It looks as though the clips that hold it on all failed. This seems to be a known issue with this model of car.

Mar 14, 2023

In October, 2022 I was traveling on interstate 75 in GA. Heard a strange sound in front of vehicle. When I stopped later, I noticed that the trim along the edge of my windshield was no longer there. Upon arriving in FL, later that week, I had Sunrise Ford in Ft. Pierce replace that windshield trim. They said that it was a pretty common problem.

Feb 03, 2023

UNKNOWN OR OTHER,STRUCTURE

2 complaints

I was driving in the highway and one of the roof racks went off flying and almost hit the car behind me. After I stopped I checked the other rack and it is also lose and coming off.

Dec 08, 2022

IN JANUARY 2021 I had a recall for the roof rails on my 2017 Ford Explorer - it took them a year to get the parts due to covid but they finally fixed the roof rails. About one month ago the roof rails started to pop back up - I made appointment at local Ford Dealership in Fuquay Varina, NC. The told me the recall was closed and they were not responsible for them coming up again as they repaired them for the recall. Once recall is closed out that is it .. nothing can be done. Is this correct? They finally agreed to cover 60 percent and I would have to pay 40 percent. Is this correct. Why should I have to pay out of pocked when the repair did not fix the problem. I contacted Ford at [XXX],[XXX] and they told me the same thing and said I only had until December 21 to make a decision. How can this be fair. Please help. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Dec 02, 2022

STEERING,FORWARD COLLISION AVOIDANCE

2 complaints

April 5th 2022 I took my 2017 ford explorer limited to City Ford here in Columbia City Indiana because the steering was sticking. It had been sticking slightly at times for several weeks prior to this. They couldn't find any problem. So in June 2022 my wife and I load up and leave for Virginia for vacation. The slight sticking got worse after several hours on the road, and finally the driver assist went out completely. making it most difficult to steer. A dangerous situation. Also I had no hill descent, no 4 wheel drive, park assist, cruise control. A multitude of warnings. I took it to Barton Ford in Suffolk Va. and was told it needed a rack and pinion steering which cost me over $3100.00 and over $600.00 for a rental during the time it took to complete the job. I noticed that I was charged for new bolts also. I researched and found that there was a previous recall on a select few of these explorers due to bolt failure. My explorer should have been selected, but there is no open recall on this explorer. Barton Ford told me that my vehicle wasn't effected by the recall. I believe Ford Motor Company should reimburse me for what it cost me.

Jul 02, 2022

WE BOUGTH THE CAR ON AUGUST 2019 WITH 4700 MILES. IN NOVEMBER 2019 THE CAR STARTED OCCASIONALLY (3 TIMES DURING 3 MONTH PERIOD) TO SOUND THE REVERSE ALARM SENSOR WHILE DRIVING. THEN CAR DIDN'T START, SO WE CHANGED THE BATTERY. IN MID MARCH, AFTER TAKING MY 3 KIDS (OUR DAUGHTER 6 AND THE TWINS WERE 2) TO THE PARK, THE CAR WILL START BUT THE STEERING WHEEL WAS NOT TURNING. IT WAS JUST STOCK AND HARD TO MOVE. WE ARE SO GRATEFUL THAT THIS DIDN'T HAPPEN WHILE DRIVING. WE COULDN'T TAKE IT TO THE DEALER BECAUSE OF THE PANDEMIC (WE DIDN'T WANTED TO EXPOSED OURSELVES TO ANY OTHER PEOPLE). FINALLY IN SEPTEMBER, THE CAR WAS TOWED TO THE DEALER. THEY CALLED THE FOLLOWING DAY AND EXPLAINED THAT TO REPAIR WILL COST US $ 1790. PLUS OTHER REGULAR ITEMS THAT NEEDED TO BE DONE FOR A TOTAL OF $2098. WHILE I DO UNDERSTAND THAT MANUFACTURING ERRORS DO HAPPEN, STILL I CAN'T COMPREHEND THE FACT THAT THE CAR IS 50519 MILES AND ALREADY NEEDS THESE EXPENSIVE REPAIRS THAT COULD HAVE CAUSE A VERY DANGEROUS ACCIDENT TO MY FAMILY. THIS IS OUR FAMILY CAR! I DRIVE MY KIDS TO SCHOOL AND TO THE PARK EVERY DAY. HOW COME SOMETHING THIS SERIOUS IS NOT PUT ON A TEST BEFORE PUTTING A CAR INTO THE MARKET (?). BUT, MORE THAN BEING VERY DISAPPOINTED AND SHOCKED FROM WHAT HAPPENED AND I FIND THE SITUATION VERY IRRITATING. NEW CARS SIMPLY DON'T DO THAT. I WOULD LIKE TO PLEASE HELP ME UNDERSTAND WHAT HAPPENED TO OUR FAMILY CAR AND I WOULD LIKE FOR YOU TO ENSURE THIS WONT HAPPEN AGAIN, I AM SCARED OF DRIVING MY FAMILY IN THE CAR AND EXPOSE THEM TO SOMETHING LIKE WHAT HAPPENED. IS THERE A RECALL FOR THIS? SHALL WE GIVE WARNING TO OTHER CAR OWNERS? THIS IS VERY DANGEROUS!

Mar 16, 2021

EQUIPMENT

2 complaints

The touch screen on the vehicle lags. It takes forever to go to stations. Changes to stations you haven’t pressed. Navigation doesn’t work properly. Phone Bluetooth doesn’t work properly. Informed the APIM NEEDS REPLACED. After researching, it appears a long list of ppl have the same complaints or very similar in nature. I think this should be investigated.

May 23, 2022

I HAVE A 2017 FORD EXPLORER. THE PASSENGER SIDE WINDSHIELD TRIM RIPPED OFF AS I WAS DRIVING APPROXIMATELY 55 MPH AND FLEW UP IN THE AIR AND LANDED BEHIND ME. FORTUNATELY, THERE WAS NOT A VEHICLE BEHIND ME. THE DRIVER'S SIDE WAS LOOSE, AND I GLUED IT DOWN WITH GORILLA GLUE AS A TEMPORARY HOLD. SINCE THAT TIME, I HAVE NOTICED MANY EXPLORERS WITH THE SAME MISSING WINDSHIELD TRIM. I FEEL THIS POSES A DANGER NOT NECESSARILY TO THE DRIVER, BUT OTHER DRIVERS ON THE ROAD.

May 12, 2021

STEERING,ENGINE,FUEL/PROPULSION SYSTEM

2 complaints

INCREASING THE RISK OF A CRASH

Dec 27, 2021

AS I WAS REVERSING I PLACED THE VEHICLE FROM REVERSE TO DRIVE AND IT BECAME VERY HARD TO TURN THE STEERING WHEEL. ON SEVERAL DIFFERENT OCASSIONS THE EXHAUST HAS BLOWN SMOKE AND THE VEHICLE SMELLS LIKE FUMES AFTER TURNING IT ON.

Oct 28, 2018

STEERING,VEHICLE SPEED CONTROL,UNKNOWN OR OTHER

2 complaints

AS I WAS DRIVING THE EXPLORER THE CROSS TRAFFIC ALERT SENSORS WENT HAYWARE, THEN THE NAVIGATOR, RADIO, HVAC, AND EVERYTHING ELSE FROZE DID COMMANDS ON ITS OWN. THE PART ASSIST MODE CAME ON IT OWN, STEERING WHEEL CONTROLS WOULD NOT WORK AND CAR STARTED TO TAKE CONTROL. VERY SCARY AS THE CAR WAS TAKING COMMANDS I COULD NOT CONTROL. TOOK IT TO THE LOCAL FORD DEALER WHERE IT WAS DETERMINED TO BE THE ACCESSORY PROTOCOL INTERFACE MODULE (APIM). MY VEHICLE IS JUST OUT OF WARRANTY AND FORD MOTOR COMPANY WOULD NOT HELP. VERY DANGEROUS, COST ME $1,200. FORD HAD THIS SAME PROBLEM ON EARLIER MODELS AND RECALLED, BUT NOT ON MINE. THIS FAILURE NEED TO BE ADDRESSED AND IF NOT FIXED COULD LEAD TO A SERIOUS ACCIDENT. FORD NEEDS TO ISSUE A RECALL. FORD WAS NO HELP TO ME, VERY DISAPPOINT IN FORD AND THEIR NEGLECT TO MINE AND MY FAMILIES STAFEY.

Apr 22, 2020

THE CRUISE CONTROL AT MY SPEED OF 65 MPH STOPPED ALONE CAUSE THE CAR TO BREAK MAKING ME LOOSE CONTROL, 2ND THE VOICE COMMAND DON'T WORK OR RESPONDING, TO HELP NAVIGATION OR PHONE PERPOUSE ( DON'T USE CELL WHILE DRIVING) AROUND DECEMBER 2018 BRING TOTHE ATTENTION OF THE DEALER AT SERVICE AND THE MISS. KENYA AFTER I PICK THE CAR SHE MANSION THAT THE RESET TO THE MANUFACTURE DAY WAS RELASED , BUT THE PROBLEM CONTINUE AS TODAY 10/07/2019 ON JUNE THE BATTERY EXPLODED, AND THANK GOD HOW NO BODY GET INJURY. THE CAR IS LEASING FOR 3 YEARS , ALL PROBLEM STARTS DECEMBER 2018 , PLUS THEARE IS A RECALL, AND FORD SAYVILLE IN 5686 SUNRISE HGWY , SAYVILLE, NY 11782 631 567-3800. REFUSE TO REPAIRE THE ISSUES, CLAIM THE CAR IS MILE COVERAGE IS OVER, BUT THE PROBLEM STRAT BEFORE PLUS ALL THIS IT'S MANUFATURE ISSUES, PLEASE HELP ME.

Oct 07, 2019

STRUCTURE,SEATS

2 complaints

ON 09/11/2019, AT APPROXIMATELY 6PM, WE WERE TRAVELING NORTH ON WV SR2 NORTH APPROXIMATELY 2.5 TO 3.0 MILES NORTH OF THE SR2 I-77 INTERCHANGE. 2017 FORD EXPLORER WAS STOPPED, WAITING ON OPPOSING TRAFFIC TO CLEAR, IN ORDER TO MAKE A LEFT HAND TURN INTO THE PARKING LOT OF CHURCH. VEHICLE WAS REAR-ENDED BY A DODGE DAKOTA PICKUP TRUCK IMPACTING SLIGHTLY OFF CENTER TOWARDS THE DRIVER SIDE OF THE VEHICLE. THERE WERE 4 OCCUPANTS OF THE EXPLORER. THE DRIVER WAS A 39 YEAR OLD MALE. THE FRONT PASSENGER WAS A 36 YEAR OLD FEMALE. IN THE SECOND ROW WERE THE OTHER 2 PASSENGERS. ON THE DRIVERS SIDE WAS A 4 YEAR OLD FEMALE, FORWARD FACING IN A GRACO EXTEND2FIT CAR SEAT. THE PASSENGER SIDE WAS OCCUPIED BY A 7 YEAR OLD MALE IN AN EVENFLO BOOSTER SEAT. ALL PASSENGERS WERE WEARING APPROPRIATE RESTRAINING DEVICES. ALL PASSENGERS WERE SHAKEN UP, WITH EXTERNAL INJURIES TO BOTH DRIVERS SIDE OCCUPANTS. THE PROXIMATE CAUSE OF THE INJURIES WAS DUE TO FAILURE OF THE DRIVER'S SEAT. THE SEAT BASE EXPERIENCED A FAILURE CAUSING THE SEAT BACK TO FALL BACK ONTO THE 2ND ROW PASSENGER, STRIKING THE PASSENGER, AND THE HEADREST BENT AND PARTIALLY DETACHED. PRIOR TO THE ACCIDENT, THE SEAT BACK WAS FULLY UPRIGHT AND THE SEAT WAS RESTING UPON THE LEGS OF THE JUVENILE FEMALE AFTER IMPACT. SHE SUFFERED CONTUSIONS TO HER LEGS FROM THE SEAT IMPACTING HER AND SHE SUFFERED A CONCUSSION AND LACERATION (REQUIRING 9 EXTERNAL SUTURES AS WELL AS SOME INTERNAL ONES) ABOVE HER RIGHT EYE, CAUSED BY EITHER THE HEAD OF THE DRIVER OR POSSIBLY THE HEADREST. THE DRIVER OF THE VEHICLE SUFFERED A LACERATION TO THE CROWN OF HIS HEAD REQUIRING 9 STAPLES TO CLOSE. THE DRIVER AND THE JUVENILE FEMALE WERE TRANSPORTED TO MARIETTA MEMORIAL HOSPITAL IN MARIETTA OH WHERE THEY RECEIVED TREATMENT AND WERE RELEASED. RESPONDING TO THE SCENE WAS THE WAVERLY VFD AS WELL AS THE WOOD COUNTY SHERIFF'S OFFICE AND ST. JOSEPH'S AMBULANCE SERVICE.

Sep 13, 2019

Crash: 1

Injuries: 2

VEHICLE WAS INVOLVED IN A 2 VEHICLE ACCIDENT. EXPLORER WAS REAR ENDED BY A VEHICLE (DODGE DAKOTA PICKUP TRUCK) TRAVELING APPROXIMATELY 55 MPH WHILE EXPLORER WAS AT A STOP, WAITING TO MAKE A LEFT HAND TURN. THE IMPACT WAS SLIGHTLY OFF CENTER TO THE DRIVER SIDE. THE DRIVER SEAT BACK COLLAPSED BACKWARDS CAUSING DRIVER AND REAR PASSENGER TO COLLIDE RESULTING IN LACERATIONS AND HEAD INJURIES TO BOTH.

Sep 12, 2019

Crash: 1

Injuries: 2

TIRES,UNKNOWN OR OTHER

2 complaints

MANUFACTURER: FORD MOTOR COMPANY , HANKOOK TIRE AMERICA CORP. VEHICLE IDENTIFICATION NO. (VIN): [XXX] SUMMARY: PURCHASED 2017 FORD EXPLORER OCTOBER 2017 WITH ORIGINAL HANKOOK VENTUS S1 NOBLE2 255/50R20 105H TIRES. HAVE 28,000 MILES AND HAVE BEEN ROTATED AT EACH OIL CHANGE; HAVE BEEN EXPERIENCING LOW AIR PRESSURE READINGS, EXTREME TREADWEAR AND 1EA TIRE FAILURE (SEPARATION (WHILE IN MOTION)). ...THIS IS ANOTHER DANGEROUS ISSUE SIMILAR TO THE FIRESTONE DISASTER. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Nov 09, 2018

HANKOOK TIRES SHOW PREMATURE WEAR ON ALL 4 TIRES. 255/50R20 105H ARE WORN 60-65% AT 17,600 MILES ON VEHICLE (15 MONTHS OLD). TIRES WERE ROTATED EVERY 5,500 MILES.

Jun 19, 2018

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,FUEL/PROPULSION SYSTEM

2 complaints

I PURCHASED MY FORD EXPLORER 2017, IN SEPTEMBER OF 2016, I HAVE RETURNED BACK TO THE DEALER MORE THAN 10 TIMES LESS THAN A 2 YEAR PERIOD. MY FIRST PROBLEM WAS THE TRUCK WOULD NOT GET ENOUGH SPEED, UNLESS I HIT THE GAS 2 OIR 3 TIMES, THE DEALER CAME IT WASN'T A PROBLEM UNTIL THE ENGINE LIGHT CAME ON, AND THAN I WAS TOLD IT WAS A RECALL ON IT, BUT WHEN I CHECK, THERE WAS NO RECALL ON MY VIN. I HAVE 5 BATTERIES SINCE I HAD THE TRUCK, I ASK THEM WHAT IS CAUSING THIS, I NEVER GET A RESPONSE. MY AC/HEAT WENT OUT, I TOLD THEM, I NOTICE SOMETHING COMING IN THROUGH THE VENTS. I INFORMED THE DEALER'S REPAIR DEPARTMENT THAT IT SMELLED LIKE A ROTTEN EGG OR JUST LOOK LIKE AIR COMING IN THE VENTS. I NEVER GOT AN ANSWER TO THAT QUESTION. I TRIED CALLING FORD CORPORATE OFFICE, BUT KNOW ONE NEVER RETURNED MY CALL.

Sep 24, 2018

I HAVE ENCOUNTERED TOO MANY ISSUES WITH THIS VEHICLE, MY BIGGEST ISSUE HAS TO DO WITH WHAT I THOUGHT I WAS HAVING A "FALLING ASLEEP AT THE WHEEL" ISSUE. THERE WERE A FEW TIMES LAST WINTER, AFTER LETTING THE CAR SIT STATIONARY AND WARM UP , THAT I COULDN'T "STAY AWAKE" WHILE DRIVING HOME ON THE FREEWAY. IT HAPPENED ONCE, TWICE, THEN CONTINUED, AND IT BECAME APPARENT IT WAS THE VEHICLE, NOT ME, THAT WAS CAUSING THIS. IT CAN BE BEST DESCRIBED AS THE SENSATION RIGHT BEFORE BEING PUT UNDER FOR A MEDICAL PROCEDURE. I WOULD THEN COME OUT OF THIS UNCONCIOUS STATE IN POTENTLALLY DEADLY DRIVING SITUATIONS. I ALSO NOTICED THAT MY DOG WAS BEING AFFECTED AT THE SAME TIME. I COULD SEE HIM GETTING ANXIOUS NEXT TO ME, AND THEN HAVE WHAT LOOKED LIKE A PANIC ATTACK UNTIL I PUT THE WINDOW DOWN. HE WOULD KEEP HIS HEAD OUTSIDE THE VEHICLE FOR A MAJORITY OF THE RIDE. I BASICALLY STOPPED USING THE HEATER. AT THE SAME TIME, THE BATTERY KEPT DYING, AND THE VEHICLE WOULD SHUT DOWN AND GO INTO A "BATTERY SAFE" MODE, AND IT NEEDED TO BE JUMPED EVERY OTHER TRIP. WHEN I TOOK THE CAR TO THE DEALER, THEY BASICALLY SAID THERE MAY BE A PROBLEM, BUT THEY DIDN'T HAVE THE REPLACEMENT PARTS, AND WOULD CALL ME WHEN THEY GOT IN. I NEVER HEARD BACK FROM THEM. THIS IS MY 3RD AND LAST LEASE WITH FORD, MY PREVIOUS 2 EDGES BOTH HAD NUMEROUS ELECTRICAL ISSUES, INCLUDING LOOSING POWER WHILE DRIVING. NOW, I'M IN AN UNSAFE VEHICLE, AND THEY WON'T EVEN ACKNOWLEDGE THE PROBLEM. I WANT OUT OF MY LEASE, BUT IN MY EXPERIENCE WITH FORD, THE CONSUMER LOOSES EVERY TIME. CAN'T FIGHT THEM IF THEY DON'T ACKNOWLEDGE THE PROBLEM. I'M PRAYING FOR MY LIFE, AND OTHER DRIVERS LIVES THAT SOMETHING GET RESOLVED QUICKLY BEFORE SOMEONE LOOSES THEIR LIFE. DOESN'T SEEM FAIR THAT THE CONSUMER HAS TO PAY FOR THE COMPANIES SHORTCOMINGS...

Jun 29, 2018

ENGINE AND ENGINE COOLING,UNKNOWN OR OTHER

2 complaints

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. THE CONTACT STATED THAT THE CARBON MONOXIDE BOX ALERTED THAT THERE WAS CARBON MONOXIDE INSIDE THE VEHICLE. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND ADVISED THE CONTACT TO TAKE THE VEHICLE TO A LOCAL DEALER. THE FAILURE MILEAGE WAS 18,000. UPDATED 09/06/17 *BF *CN

Aug 04, 2017

TWICE SINCE PURCHASING MY NEW EXPLORER I HAVE GOTTEN DEATHLY ILL WHILE DRIVING, HAD TO PULL OVER AND BE TAKEN BY AMBULANCE TO THE EMERGENCY ROOM. I'M 70 YEARS OLD AND HAD THOUGHT IT WAS A MEDICAL ISSUE. HOWEVER, I HAVE BEEN POKED AND PROBED FOR EVERY POSSIBLE ALIMENT AND ALL HAVE COME BACK NEGATIVE AND AM IN GREAT HEALTH. EVEN MY HEART TESTS WERE OUTSTANDING. I SAW THE EXPLORER STORIES ON THE NEWS, LOOKED UP CARBON MONOXIDE POISONING AND NOTE THOSE WERE THE SYMPTOMS I HAD. IN THE INCIDENT LAST WEEK I WAS FEELING WORSE AND WORSE AS I DROVE AND WAS JUST ABLE TO GET OFF THE ROAD BEFORE I PASSED OUT, MY VISION HAD GONE BLANK, I STARTING SWEATING WITH THE AIR ON, AND I BECAME EXTREMELY DIZZY AND DISORIENTATED. I SPENT TWO DAYS IN THE HOSPITAL THINKING I WAS DYING BECAUSE THAT'S HOW I FELT. I'M IN EXCELLENT HEALTH, BIKE 20 MILES DAY 2-4 DAYS WEEK, PLAY LEAGUE HOCKEY, AVID GOLFER THAT HAS COMPETED AT THE NATIONAL LEVEL, ETC. THIS WAS NOT A 'ILLNESS', I'M CONVINCED IT WAS CARBON MONOXIDE POSIONING. UPDATED 11/06/2017*JS THE CONSUMER REQUESTED A STATUS UPDATE. UPDATED 12/07/2017*JS *JS THE CONSUMER STATED THAT HE PASSED OUT WHILE DRIVING THE VEHICLE AND REQUIRED HOSPITILIZATION. *JS

Jul 27, 2017

Injuries: 1

STRUCTURE,UNKNOWN OR OTHER,ENGINE

2 complaints

I AM CONCERNED ABOUT MY 2017 FORD EXPLORER AND A CARBON MONOXIDE LEAK. I HAVE OVERALL FEELING BAD SINCE WE GOT OUR NEW 2017 FORD EXPLORER, WHICH IS VERY OUT OF CHARACTER FOR ME. I AM A PRIOR SPECIAL OPERATION VETERAN, OVERALL IN GOOD HEALTH, AND ONLY 30Y/O. LIKE MANY, WHO HAVE COMPLAINED ABOUT THIS VEHICLE I AM GETTING NAUSEA, WEAKNESS, AND TENSION HEADACHES FROM DRIVING THIS VEHICLE. I HAVE BEEN VERY WEAK AND HAVING HEADACHES, AS OF LATE. THIS HAS HAD A MAJOR IMPACT ON MY DAY-TO-DAY LIFE. I COULDN'T EXPLAIN WHY OR WHAT WAS GOING ON WITH ME IT SEEMED AS IF IT CAME OUT OF NOWHERE. I AM STARTING TO THINK MAYBE I HAVE LONG TERM EXPOSURE TO CARBON MONOXIDE OVER THE LAST 3 WEEKS. I GOT THE FORD EXPLORE 3 WEEKS AGO AND THIS SUDDEN SICKNESS HAS BEEN HAPPENING SINCE THEN. I GOT SO WORRIED WITH MY HEALTH"I WENT TO THE DOCTOR. I EXPLAINED TO THE DOCTOR "I HAVE NO CLUE WHAT'S GOING ON WITH ME BUT I FEEL ABSOLUTELY HORRIBLE. I FEEL LIKE I HAVE HAD A FLU FOR ALMOST A MONTH". I WAS DESPERATE AND I KNOW I SOUNDED CRAZY BUT I HAVE BEEN HAVING SOME SERIOUS BOUTS WITH WEAKNESS, FATIGUE, AND HEADACHES. I WENT TO THE DOCTOR ON JULY 31ST 2017 AND I REALLY HAVE BEEN BAFFLED BY THE SUDDEN ONSET OF SYMPTOMS. THIS WAS BEFORE I KNEW ABOUT THE NHTSA INVESTIGATION INTO THE 2017 FORD EXPLORER. I SAW THE STORY RUN TODAY (8-3-17) ON GOOD MORNING AMERICA AND I STARTED TO PUT TWO AND TWO TOGETHER. AT THE DOCTOR'S APPOINTMENT ON (7-31-17) THEY PULLED BLOOD, AND ARE CONDUCTING A BUNCH OF TEST BUT NOTHING HAS COME BACK. I AM CONCERNED, I AM HOPING IT'S NOT RELATED TO THE CARBON MONOXIDE LEAK THAT OTHERS ARE REPORTING. MY BIGGEST CONCERN IS FOR MY PREGNANT WIFE AND UNBORN CHILD. AS A PURPLE HEART VET I HAVE PUT MY HEART AND SOUL INTO OUR GREAT COUNTRY AND I NEED THIS AGENCY TO PLEASE FIND ANSWERS TO IF THESE SUVS ARE SAFE. MY FAMILIES COULD DEPEND ON IT THANK YOU FOR YOUR SERVICE.

Aug 03, 2017

Injuries: 1

THE VEHICLE WAS TESTED AND FOUND TO HAVE 18 PPM OF CO IN THE INTERIOR WHILE IN OPERATION.

Jul 31, 2017

STEERING,LANE DEPARTURE

1 complaint

When driving and going to make a turn or change lanes . The steering wheel will stick and have a little jerk . Had it looked at but could not find anything. It’s been happening since July . I’m afraid it might not turn when I want it to . My husband did notice it when I drove him to airport . Wondering if recall on this .

Oct 11, 2025

ELECTRICAL SYSTEM,ENGINE,BACK OVER PREVENTION

1 complaint

Ya me marco el funcionamiento del motor

Oct 09, 2025

ELECTRICAL SYSTEM,AIR BAGS,VEHICLE SPEED CONTROL

1 complaint

Constant fail of O2 sensor and ABS causing check engine and ABS lights to come on. After diagnosis, did research and it is a common problem on Ford Explorers

Sep 13, 2025

SUSPENSION,POWER TRAIN

1 complaint

Delayed in transmission in gauging when going down hills especially going up them and causing vibration slowing down while vehicle moving.This is Ford Explorer XLT model 2.3 motor type 6 Speed automatic VIN:[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Jul 18, 2025

ELECTRICAL SYSTEM,SEATS,UNKNOWN OR OTHER

1 complaint

The following is a letter I sent to Ford. I've yet to hear back from them. This is a picture of what happened in my 2017 Explorer on Thursday, June 5, 2025. As I unlocked and got into my car, I realized the seat was moving forward. I tried to get out of the seat, but it was difficult because the space was closing in. I managed to squeeze out of the space before it totally closed me in and pinned me between the seat and steering wheel. As you can see from the picture, the seat is as close to the steering wheel and console as possible. The steering wheel was 7 inches from the seatback and 7 inches from the seat bottom. The seat was 2 inches from the console. This is extremely dangerous. This is not the first time this has happened. This has occurred at least ten times. Sometimes it is when I get in the vehicle as happened June 5. One time I was pinned between the steering wheel and seat and my legs were jammed into the console. Fortunately, I was able to extricate myself with only a few scrapes and bruises. While it is happening, I try the side buttons that control the seat and other ways to stop it, but nothing I do stops the movement once it begins. The only way to avoid being pinned in is to get out while the seat is moving. Other times it has happened when I am not in the car. I unlock and open the door to get in and the seat has moved itself and is as far up to the steering wheel as physically possible. The first time this happened; I told the service desk at the dealer when I was having work done on the SUV. They checked and said they couldn’t find anything wrong with it.`

Jul 08, 2025

ELECTRICAL SYSTEM,EXTERIOR LIGHTING,SEATS

1 complaint

There is a constant drain on the battery and overnight the battery can go dead. I replace the battery every 6 months to a year and have been doing that ever since we purchased it. The dealership wants $250 to diagnose it. It's been a problem from day 1. Even when we took it to get serviced and they kept it overnight - the same thing happened at the dealership, but they just ignored it. That was when it was under warranty. I read on the internet that several people have this same problem. I feel this should be a recall. I have a 2017 Ford Platinum

Jun 05, 2025

VEHICLE SPEED CONTROL,ENGINE

1 complaint

At 28,000 miles, the vehicle emitted black smoke from the exhaust. Despite the mechanic’s efforts to identify the issue, no diagnostic codes were detected. Currently, the vehicle has accumulated 100,000 miles. The engine suddenly lost the ability to accelerate beyond 20 miles per hour. After several months of repairs involving multiple turbo replacements, it was determined that the engine was severely damaged and should have been replaced over 50,000 miles ago. The engine was subsequently replaced, but only a year later, it failed again. After replacing the first engine, the vehicle’s performance deteriorated significantly. The vehicle required another visit to the shop for several months, resulting in another engine replacement. Over the course of several months, the vehicle lost all power and exhibited difficulty shifting into reverse. Consequently, it failed to reverse and was involved in an accident.

Jun 03, 2025

Crash: 1

STRUCTURE,TIRES

1 complaint

The contact owns a 2017 Ford Explorer. The contact stated that the A-pillar trim on the driver's and passenger’s side of the windshield was loose at the top. Additionally, the contact stated that the TPMS warning light was illuminated. The contact received notification of NHTSA Campaign Number 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was 125,000. VIN tool confirms parts not available.

Mar 10, 2025

POWER TRAIN,ELECTRICAL SYSTEM,SEAT BELTS

1 complaint

Passenger seatbelt frayed, inside electrical goes haywire when cold weather, transmission slipping was rebuilt under warranty lasted one week and is slipping again shifting hard, B panels falling off A panel was recalled but panel wasn’t?

Mar 09, 2025

STEERING,STRUCTURE,AIR BAGS

1 complaint

The contact owns a 2017 Ford Explorer. The contact stated that the passenger’s side the A-pillar applique trim had a split in the middle causing rainwater and dirt to enter the vehicle. As a result of the failure, the sunroof motor was damaged and then failed to operate. The local dealer was called, and the contact was made aware of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not available. On another occasion, while driving at various speeds, while making a left or right turn there was an abnormal clicking sound coming from the steering. The contact stated that the failure progressively worsened when turning to the right. The vehicle was taken back to the same dealer where it was diagnosed that the A-pillar applique trim was not likely the reason for the failure of the sunroof motor and that a 2-hour diagnostic test needed to be completed to determine the cause of the failure; however, the repair would be paid out of pocket. The contact was reminded that the A- Pillar applique trim part was still not available. The contact was informed that the clock spring had failed and needed to be immediately replaced. The vehicle was not repaired and remained with the dealer. The manufacturer was notified of the failure. The approximate failure mileage was 60,000.

Oct 29, 2024

ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

Driving on the highway heard large rattling noise coming from engine loss of power engine light came on battery light came on no acceleration cause to slow down on highway fortunately I was able to get to shoulder had it towed to service shop had p0012 code tensioner may have broken off on timing belt causing low oil pressure and causing engine rattling noise and engine shut down but service garage don’t do that type of work

Aug 31, 2024

STRUCTURE,UNKNOWN OR OTHER,VISIBILITY/WIPER

1 complaint

In addition to the details involving NHTSA Safety Recall 24V031, any trim at the top of the windshield has either deteriorated or fallen completely off, while the material below the windshield is rotting away. This all makes me worry that the windshield could potentially shatter or come off on the road. I am not sure when the problem occurred or started to occur and I just became aware of it.

Aug 27, 2024

SERVICE BRAKES,ENGINE

1 complaint

While going up a steep hill or mountain the car starts to over heat when you stop pressing the gas the car will start to go back down in to cooler numbers and you can start driving again with no issues until you hit another hill.. car breaks wear out excessively also the car jerks when going into gear to shift

Jul 24, 2024

POWER TRAIN,VEHICLE SPEED CONTROL

1 complaint

The contact owns a 2017 Ford Explorer. The contact stated that the vehicle was experiencing rough idling while in drive(D) and reverse(R). Additionally, the contact stated that while driving from a complete stop and depressing the accelerator pedal, the vehicle hesitated while responding. The contact stated that upon depressing the accelerator pedal closer to the floorboard, the vehicle responded as needed. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where it was determined that the failure was related to Ford Campaign Number: 20N07. The dealer was contacted and informed the contact that the vehicle was not covered under the Campaign. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 98,000.

Jul 01, 2024

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,STRUCTURE

1 complaint

Our Explorer, experienced this in June of 2022. My daughter had just graduated college and we were moving some of her stuff back home 350 miles away. The Driver side area where the codes are put into to unlock the door if locked out, fell off and was hanging while we were driving on the freeway. We had to exit the freeway and my husband had to buy duck tape to tape it up. Our hatchback would not work as well as some of the other electrical things. I refused to drive it the rest of the way home, and we switched cars. It did cause electrical to go out throughout the car, intermittently. My husband had to buy the part online and replace it. The passenger side is going to fall off also, I noticed while washing it. So yes we need this done, asap. And we had to incur charges for having to replace the other one. There were warning lights for electrical, not working. I cannot remember what they were.

Feb 27, 2024

ELECTRICAL SYSTEM,STRUCTURE,VISIBILITY/WIPER

1 complaint

All plastic parts around all doors and windows have become detached. Windshield wipers do not stay on. All lights and gps go haywire and flash on and off gps system goes off and makes loud buzzing noise

Feb 15, 2024

POWER TRAIN,UNKNOWN OR OTHER

1 complaint

While driving my 2017 Ford Explorer, There was a smell of burnt oil/tire entering my vehicle through the vents. I took it in to the Ford Dealership and I was advised that I needed a brand new transfer case, and the front engine mounts needed to be replaced due to broken seals. This was causing transmission fluid to leak onto other parts (hot) which was causing the smell while I was driving. My vehicle is at 89,000 miles, and if I don't get this replaced, then it will cause transmission failure. I was told that this should not happen on a vehicle with 89,000 miles. The leaking fluid can also cause a fire under the hood. When asked why or how this could happen, I was told it just wasn't "built" well. Cost of repairs will be about $4,500.00. WOW.

Feb 07, 2024

SUSPENSION,WHEELS

1 complaint

Rear toe joint arm used to replace recalled rear toe joint arm is causing the tires in the back to tilt leaving vehicle at risk of roll over accident from tire, axel, or suspention failure. The suv becomes increasingly unstable and difficult to control. The mechanic said it was a miracle that my suv had not flipped. When I took this issue to the dealership, the service manager was aware of the issue and had a "high percentage" of cars that had the recall service done returning with the same problem. Despite this information being passed on to ford by its dealership service departments, Ford is continuing to place drivers at risk by using the toe joint arm that is too small. Pictures: rear vs front tires purchased same time, allign.before new toe joint placed with report, then after, recall work done and , allign report, toe joint arms used for recall. Date below is when my car was taken out of service for safety. Most driving speeds 25 to 35 mph zones.

Jan 24, 2024

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,ENGINE

1 complaint

Car dies repeatedly while on the road driving and also while parked. Car has errors on dashboard when attempting to turn on, which I have a video of. First mechanic was able to replicate issue once and got some scan tool codes but he said after that, they all cleared out and he wasn't able to replicate. Car was given back to us, drove to store died and it wouldn't start in parking lot. Mechanic sent tow truck, car started when tow truck arrived. Took car to Ford, tech unable to replicate, car returned to us. Car died once again, which is when I took the error video and took the car back to Ford and showed service rep the video. Ford still unable to figure out the issue. We told Ford to keep the car because it isn't safe to drive until we find and fix the issue. Car has been in mechanic and Ford for about 4 months total.

Dec 04, 2023

EXTERIOR LIGHTING,STRUCTURE

1 complaint

Driver's side A-Pillar trim fell off while driving at highway speed

Nov 16, 2023

ELECTRICAL SYSTEM,EXTERIOR LIGHTING,UNKNOWN OR OTHER

1 complaint

I had a piece of window trim fly off while I was driving on the highway at 70 mph. When it flew off, it may have hit another car. With the piece gone, I am not unable to open the hatch and the dome lights stays on for a considerable amount of time. There is no way to turn off the dome lights, you have to wait for them to go off, which is sometimes more than 10 minutes. When the piece was replaced, the hatch worked as normal. I had the window trim replaced and the same thing happened. I was traveling down the highway over 70 mph and the piece flew off in heavy traffic. I, again, have not been able to open the hatch nor turn off of the dome lights.

Aug 18, 2023

UNKNOWN OR OTHER,LANE DEPARTURE

1 complaint

This vehicle has many blind spots and the blind spot alert only works sometimes. The locks only work sometimes too. It consistently does not lock the passenger side door with the lock or the key fob. When I was in traffic someone was able to open the door.

Jul 25, 2023

ENGINE,FORWARD COLLISION AVOIDANCE

1 complaint

My suv begin to run hot and instantly water begins to boil and I was trying to pull off the road immediately.with no warning from the forward collision as a car hit me. Got a quote from many dealerships or mechanics who says that the water pump failed and is a common problem with my suv and it quoted 2500 with a two week time frame because the water pump is built inside the engine no one wants to work on it due to risk. Help!

Apr 01, 2023

Crash: 1

Injuries: 2

POWER TRAIN,WHEELS,ENGINE

1 complaint

Need a new transmission when I need to press the gas it won’t go it like I’m just pushing the gas in park

Mar 13, 2023

STRUCTURE,VISIBILITY

1 complaint

The contact owns a 2017 Ford Explorer. The contact stated while driving 65 MPH, the driver's side front window trim detached. The contact pulled over but was unable to locate the window trim. The dealer was made aware of the failure and confirmed that the driver's side front window trim needed to be replaced; however, the replacement part was on backorder. The contact was able to purchase the replacement part online; however, he had to glue it to the front driver's side window due to fractured clips used to secure the window trim in place. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 12,000.

Feb 01, 2023

STEERING,SERVICE BRAKES,FUEL/PROPULSION SYSTEM

1 complaint

I bought the car from modern Corp s in Fort Myers Florida and the brakes are bad the catalytic converters are melted the steering makes noise sounds like it's just going to break in half we have a warranty and they will not honor any of it after they said they would we had to put it in the shop not even a week of having it because of the AC and the only thing the warranty covered was the sway bars ball joints and a couple other things I drive this car every single day I just feel like this car is not going to make it nobody wants to honor the word about anything and I see there is a recall for the roof rack one side of it is missing if anybody can help me that would be great because I would love to get my vehicle repaired the right way

Dec 09, 2022

AIR BAGS,VEHICLE SPEED CONTROL

1 complaint

Husband returning home, pulled into carport and as he removed foot from accelerator to brake, accelerator pedal kept accelerating. This caused explorer to hit carport awning, classic 65 mustang, 2007 Harley and shed. Airbags did not work. Accelerator is still pressed to floorboard.

Oct 14, 2022

Crash: 1

Injuries: 1

ELECTRICAL SYSTEM,LANE DEPARTURE,FORWARD COLLISION AVOIDANCE

1 complaint

We had an issue with Fuse 34, it popped and sent warning lights to the dash regarding safety systems and sensors, as well as the cameras in front and back stopped working. We replaced the fuse and it held for a while, but then popped again. I noticed a lamp flickering one day on the front of the vehicle, and upon further inspection saw that the front camera and wiring harness had started on fire. The wiring harness is fully melted and there are signs of smoke and fire damage on the front of the car. I took the vehicle to a Ford dealer who confirmed their wiring harness had failed, but will not take responsibility for the issue. The care only has about 45k miles on it. I called to their corporate office who also rejected any liability. Obviously this is more than just the money for repairs, but a safety hazard that they will not respond to.

Oct 12, 2022

Fire: 1

STRUCTURE,ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

Carbon monoxide leaking into my car—tailgate area and through the front hvac. Weird sound from engine that sounds and smells like electrical burning or something overheating.

Aug 18, 2022

SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

1 complaint

On freeway, pushed brakes but vehicle did not stop or slow down resulting in multi car rear end collision. Auto braking and ABS features did not engage. Vehicle was towed and our insurance agent claim adjuster recommended we reach out to you. No warning lamps, messages, etc. went off at the time or had gone off previously.

Aug 16, 2022

Crash: 1

ELECTRICAL SYSTEM,FORWARD COLLISION AVOIDANCE,STRUCTURE

1 complaint

Our model is a platinum explorer with the panoramic sunroof. Apparently there is a sunroof leak which due to the way the headliner is made , fills the headliner (holds like a bowl) then either spills out at the front of the vehicle or rear depending on going forward , reverse, accelerating, braking, uphill, or downhill etc. The front is worse because of the electrical in the overhead lights, sunroof motors, and lane departure at the rear view mirror. Also everything electronic below on the dashboard and center console. There are high expenses related to replacing these electronics due to water damage in addition to the driver being suddenly started by a wave of water crashing down on them while accelerating or braking.

Aug 04, 2022

POWER TRAIN,ELECTRICAL SYSTEM,BACK OVER PREVENTION

1 complaint

I backed into a parking spot, put the car in park and turned the vehicle off. As I was getting ready to get out of the car, it rolled backwards into another car parked to my passenger side rear. My vehicle did not give any warning, no sensor alert, or anything!

Jun 15, 2022

Crash: 1

SERVICE BRAKES, AIR

1 complaint

The contact owns a 2017 Ford Explorer. The contact stated that the brakes would squeak upon depression of the brake pedal without warning. The contact took her vehicle to an independent mechanic where it was discovered that the rear brake calipers needed replacement. The contact called the dealer where she was given the number to the company that handle vehicle warranty. The manufacturer was also notified of the failure and stated that they would not cover the cost of the repair. The vehicle was repaired. The failure mileage was 33,038.

Mar 30, 2022

AIR BAGS,UNKNOWN OR OTHER

1 complaint

Airbag light illuminated on dash board. No airbags in vehicle working. Have taken vehicle to the dealership 7-9 times to be serviced, always told it is a sensor that is loose or a seatbelt. This was not reported on the Carfax when I got the vehicle and started shortly after. I was once told none of the airbags in the bag of the vehicle were functioning but taping the senor (under the seat) with electrical tape fixed it. So many recalls on this vehicle, too dangerous to drive with no working airbags. Also the recall on the roof racks cause my vehicle to leak when it rained, ford service told me this was not possible. never looked at the problem and after the recall was fixed (after I asked twice) the vehicle stopped leaking, now the sunroof does not work. I have contacted Ford Cooperate about these issues also and they refused to help.

Feb 20, 2022

VISIBILITY,UNKNOWN OR OTHER

1 complaint

Both back doors of explorer closed at same time and back window completely shattered. It was cracked around edges and had a giant hole in it. (Husband took the photos and didn’t take one of whole window.)

Feb 14, 2022

SUSPENSION,WHEELS,UNKNOWN OR OTHER

1 complaint

When I had to drive with 1 inch of snow on the road it felt like my rear end was going to come out of my car. My rear end was all over the place and has been getting worse when driving in snow and rain. This is putting my children life at risk especially since there's a recall on my vehicle and there's still no parts to fix it. I want a rental car until someone gets this issues fixed! Someone is seriously going to be injured or this problem and the recall that can't be fixed. I'm scared for my safety to even drive it in the snow or rain but I have to work. This is a huge issue and I'm not sure why this is still an ongoing issue

Feb 10, 2022

SUSPENSION,UNKNOWN OR OTHER

1 complaint

I have 4 recalls on my vehicle that multiple Ford Dealerships tell me that they can not fix because of parts not being available or no remedy is available. This has been going on for almost a year now. With these recalls, I feel that my car is not safe to drive. What needs to be done.

Jan 16, 2022

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,BACK OVER PREVENTION

1 complaint

The APIM is malfunction in my 2017 explorer. Accessories stay on after vehicle turned off, killed battery, vehicle collision sensors and camera intermediate malfunction. Cruise control intermittent function, GPS and screen options /operations inoperable

Sep 01, 2021

UNKNOWN OR OTHER,ENGINE,FORWARD COLLISION AVOIDANCE

1 complaint

Initially the cars check engine light came on intermittently for about 3 days, then one day while driving the wrench light came on and the car immediately started decelerating - almost as if I was breaking hard, and would not accelerate over 30. After turning it on and off multiple times the light went away for days until my appointment with the mechanic, that same day it came back on. We went to a Ford dealership and they said it was the throttle body and repaired it. Two weeks later the same issue occurred. I know this was a big issue in 2016 and earlier models, I believe the problem was never fixed in 2017 models. Our car is currently in the shop and they are "emailing Ford" about what to do. The first incident I was on the interstate when I stopped abruptly and the second was on the highway. I luckily had no one behind me both times otherwise this could've easily caused an accident.

Jul 08, 2021

SUSPENSION,STRUCTURE

1 complaint

I HAVE 2 RECALLS THAT MY DEALER WONT FIX BECAUSE THEY WONT GET ME A RENTAL CAR WHILE MY IS REPAIRED.MY QUESTION WHO IS RESPONSIBLE IF INJURY OR DEATH OCCURS BECAUSE OF THESE RECALLS ?

May 03, 2021

SUSPENSION,POWER TRAIN,ENGINE

1 complaint

THE VEHICLE HAD LOOSE K MEMBER BOLTS, BENT STRUTS, LOOSE EXHAUST SYSTEM. THIS WAS FOUND WHEN WE TOOK VEHICLE IN FOR FIRST OIL CHANGE

Apr 22, 2021

WHEELS,SERVICE BRAKES

1 complaint

REAR BRAKE CALIPERS SEIZED AND WORE BRAKE PADS ALL THE WAY DOWN. SLIGHT INTERMITTENT SOUND WAS NOTICED WHEN CAR WAS IN MOTION BUT THOUGHT IT MAY BE RELATED TO THE ROOF RACK DETACHMENT THAT WAS PENDING REPAIR. SQUEALING BECAME PERSISTENT AND STOPPED UPON BREAKING, AND STARTED AGAIN AFTER BRAKE RELEASED. UPON IDENTIFYING THIS CORRELATION TOOK THE EXPLORER TO THE DEALERSHIP AND THIS ISSUE IDENTIFIED WAS SEIZED CALIPERS.

Apr 12, 2021

STEERING,POWER TRAIN,VEHICLE SPEED CONTROL

1 complaint

*VEHICLE MAKES POPPING NOISE *JERKS, LOSS OF POWER WHEN GOING DOWN THE ROAD, HARD TO STEER, PUSH ON GAS AND WILL NOT GO. ENGINE LIGHT AND WRENCH COME ON. CALLED DEALER WHEN FIRST HAPPENED WAS TOLD TO TURN OFF BACK ON TO RESET. HAVE WORKED WITH DEALER AND MANUFACTURE. THIS IS DANGEROUS AND I'M TERRIFIED TO DRIVE THE VEHICLE. THIS WILL BE AT LEAST THE FOURTH TIME BACK IN THE SHOP FOR REPAIRS. IN ADDITION TO SEVERAL CALLS.

Mar 22, 2021

WHEELS,FORWARD COLLISION AVOIDANCE,LANE DEPARTURE

1 complaint

LAST NIGHT ONE OF MY HANKOOK S1 NOBLE ON MY 2017 FORD EXPLORER BLEW OUT WHILE DRIVING ON THE 405 FREEWAY AND REQUIRED ME TO PULL OVER AND CHANGE THE TIRE. AT 21,000 MILES ON THE VEHICLE/ TIRES THE MECHANIC SHOP TOLD ME THE TIRES WERE BASICALLY BALD AND HAD RUBBER EVENLY ERODING (WHICH INDICATES NOT AN ALIGNMENT ISSUE). THE TIRES WERE ALSO ROTATED AND SUPPOSED TO LAST 50,000 MILES. THERE ARE ALSO MANY OTHER COMPLAINS ON THESE TIRES THROUGHOUT THE INTERNET BUT NOT RECALL HAS BEEN INITIATED BY HANKOOK. THEY HAVE ADVISED THEY WILL GIVE A PRO-RATED DISCOUNT ON NEW TIRES, WHICH IS COMPLETELY UNREASONABLE AND NEGLIGENT..

Jan 03, 2021

ELECTRICAL SYSTEM,SEATS,ENGINE

1 complaint

MY 3 YR OLD TRUCK ALREADY HAS A LEAKING COOLANT LINE WHICH COME TO FIND OUT IS DRAINING INTO THE WATER LINE IN THE ENGINE. I CAN'T DRIVE MORE THAN 5MILES BEFORE I NEED TO REFILL MY COOLANT. IN ADDITION, THE HEATING ELEMENTS IN BOTH THE DRIVER AND PASSENGER SEATS HAS GONE OUT. I THOUGHT IT WAS A FUSE AND OF COURSE ITS SOMETHING MORE.

Jan 02, 2021

ELECTRICAL SYSTEM,AIR BAGS,SEAT BELTS

1 complaint

THE SRS WARNING LIGHT ON THE DASH IS ILLUMINATED INDICATING THAT IN THE EVENT OF A COLLISION THE AIRBAGS WILL NOT DEPLOY. VEHICLE WAS TAKEN TO LOCAL FORD DEALER WHERE FAULT CODES INDICATE THAT TWO WIRE HARNESSES OR CONNECTORS NEED TO BE REPLACED. COST OF SERVICE WAS QUOTED AS $1600. HOWEVER, MILEAGE (46,500) AND AGE (4 YEARS) WOULD INDICATE THAT REPAIR SHOULD BE MADE UNDER 5 YR / 60,000 MI WARRANTY. FORD HAS DENIED WARRANTY. SERVICE DEPARTMENT AT LOCAL DEALERSHIP AND FORD CUSTOMER CARE HAVE BEEN CONTACTED BY PHONE AND EMAIL MULTIPLE TIMES WITHOUT RESOLUTION. THEY POINT TO THE WIRE HARNESS AS THE ROOT CAUSE OF THE SRS SYSTEM NOT WORKING AND CLAIM THAT THE WIRE HARNESS IS NOT COVERED BY WARRANTY.

Oct 03, 2020

POWER TRAIN,STRUCTURE

1 complaint

ABOUT A WEEK AGO MY VEHICLE WAS IDLING, BACKED STRAIGHT INTO THE TURNAROUND IN MY DRIVEWAY WITH THE CAR IN PARK. THE TWO PASSENGER SIDE DOORS WERE OPEN. MY DAUGHTERS AND I (UNBUCKLED) SAT THERE ABOUT TEN MINUTES WHILE THE ENGINE WAS CRANKED BUT IN PARK, WAITING ON MY HUSBAND TO FINISH UP GRABBING THINGS FOR THE VACATION WE WERE GETTING READY TO LEAVE ON. MY TWO YEAR OLD HAD MOVED TO THE DRIVER'S SEAT, AND I WAS IN THE PASSENGER SEAT. MY DAUGHTER REACHED OVER AND PRESSED THE PUSH TO START BUTTON AS SHE HAS A HUNDRED TIMES AND KILLED THE ENGINE, BUT THIS TIME, WHEN THE ENGINE TURNED OFF, SOMETHING OBVIOUSLY CAUSED THE TRANSMISSION TO DISENGAGE AND WE WERE SENT ROLLING DOWN THE HILL BEHIND MY TURN AROUND. I TRIED TO CLIMB OVER AND HIT THE EMERGENCY BRAKE BUT WAS UNSUCCESSFUL. WE WERE FINALLY STOPPED WHEN OUR BACK END SMASHED INTO THE SECOND TREE WE HIT. FORTUNATELY NO ONE WAS INJURED BESIDES ME, AND IT WAS RELATIVELY MINOR WITH JUST BRUISING, PARTICULARLY SINCE I'M 7 MONTHS PREGNANT. MY CAR IS NOW COMPLETELY TOTALED AS A RESULT.

Aug 02, 2020

Crash: 1

Injuries: 1

STEERING,POWER TRAIN,ENGINE

1 complaint

SLOWING DOWN HARD SHIFT @ 40 AND @20. STEERING FEELS LIKE IT WANTS TO PULL WHEN DRIVING ON A CURVE OR WHEN TURNING.

Jul 27, 2020

FUEL SYSTEM, GASOLINE,EQUIPMENT

1 complaint

2017 FORD EXPLORER BASE MODEL WE HAD OUR VEHICLE "FIXED" FOR THE CARBON MONOXIDE DEFECT ON JUNE 24, 2020. IT IS NOW 7/9/2020 AND OUR CO ALARM IN THE VEHICLE IS STILL PICKING UP AT LEAST 11PPM OF CARBON MONOXIDE IN THE CABIN OF THE VEHICLE AFTER TRAVELING AT HIGHWAY SPEEDS. THESE OCCURRENCES ARE SPORADIC, NOT CONSISTENT WITH EACH USE OF THE VEHICLE.

Jul 10, 2020

ELECTRICAL SYSTEM,EXTERIOR LIGHTING,STRUCTURE

1 complaint

ON MAY 20TH 2020, I DROVE THE CAR FROM MY HOUSE TO THE GROCERY STORE, AN APPROXIMATE 7 MILES DRIVE. I PARKED THE CAR ON THE PARKING LOT, A FEW SECONDS AFTER LEAVING THE CAR WHITE SMOKE STARTED TO COME FROM UNDER THE HOOD, AS THE SECONDS PASSED THE WHITE SMOKE CONVERTED INTO A FIRE IN THE ENGINE, 5 MINUTES LATER THE CAR WAS LOST DUE TO FIRE. *TR

Jun 12, 2020

Fire: 1

ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

TL* THE CONTACT OWNS A FORD EXPLORER. THE CONTACT STATED THAT WHEN THE VEHICLE WAS TURNED ON, THE HEATED SEATS, THE HEATED STEERING WHEEL AND THE APPLE PORT WAS INOPERABLE. THE MESSAGE CENTER DISPLAYED EMERGENCY CHARGING NEEDED. THE VEHICLE WAS STARTED AND THEN DRIVEN TO THE FRED MARTIN FORD, 4701 MAHONING AVE, YOUNGSTOWN, OH 44515, WHERE IT WAS DETERMINED THAT THE BATTERY POWER WAS LOW. THE CONTACT STATED THAT THE BATTERY WAS REPLACED PRIOR TO THE FAILURE. AN APPOINTMENT WAS SCHEDULED WITH THE SAME DEALER HOWEVER, THE DIAGNOSTIC TEST WAS STILL PENDING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 13,001.

Feb 21, 2020

POWER TRAIN,STRUCTURE,ENGINE

1 complaint

SEVERAL PROBLEMS WITH THIS EXPLORER. THERE WAS A NOISE IN THE ENGINE COMPARTMENT WHEN THE A/C IS RUNNING AND GIBBONS FORD TRIED TO FIX IT SEVERAL TIMES. THEY TIGHTENED A HEAT SHIELD TWICE. REPLACED THE IDLER AND BELT 3 TIMES AND FINALLY CHANGED THE A/C COMPRESSOR. ALSO THE HOOD BUBBLED AND THEY REPLACED THE HOOD AND REPAINTED IT. THERE ALSO WAS A TRANSMISSION LEAK AND THE ALTERNATOR HAD TO BE REPLACED. THEY ENDED UP BUYING THE VEHICLE BACK DUE TO THE ONGOING UNRESOLVED ISSUES.

Feb 14, 2020

ELECTRICAL SYSTEM,ELECTRONIC STABILITY CONTROL (ESC),VISIBILITY/WIPER

1 complaint

ON JANUARY 11, 2020, I TURNED ON THE IGNITION OF MY 2017 EXPLORER SITTING IN MY DRIVEWAY AND IMMEDIATELY HAD 4 WARNING LIGHTS AND MULTIPLE ERROR MESSAGES APPEAR. IT WAS THE ABS, STABILITY CONTROL ON AND OFF LIGHTS AND A WRENCH. THEN THERE WERE MULTIPLE MESSAGES ABOUT MY FOUR WHEEL DRIVE NOT WORKING. I TURNED THE CAR ON AND OFF SEVERAL TIMES TRYING TO GET ALL OF THE MESSAGES AND TO SEE IF IT WOULD CLEAR. AFTER THE THIRD RESTART THE ENTIRE DASH PANEL WENT OUT COMPLETELY EXCEPT FOR THE RADIO WHICH STAYED ON CONTINUOUSLY FOR 3 DAYS UNTIL IT GOT TO THE DEALERSHIP ON MONDAY. NONE OF THE VEHICLES BASIC NECESSITIES WERE WORKING...NO SPEEDOMETER, GAS LIGHTS, WIPERS, OR CLIMATE CONTROL, ETC. ONLY THE ENGINE, HEADLIGHTS, AND TAILLIGHTS WORKED. THE DEALERSHIP IS CURRENTLY WORKING ON THE VEHICLE AND IS CLAIMING IT IS A BATTERY PROBLEM. THE SERVICE DEPARTMENT HAS ADMITTED THEY DON'T KNOW IF IT WILL FIX THE PROBLEM BUT THEY ARE GOING TO TRY IT. THEY ALSO STATED THAT "THE VEHICLE CLEARED ITSELF AFTER THE BATTERY DIED WHICH IT'S NOT SUPPOSED TO DO". I HAVE SEEN MULTIPLE REPORTS ABOUT THE EXACT SAME PROBLEM WITH DIFFERENT ITEMS BEING REPLACED, INCLUDING THE BATTERY, TO NO AVAIL. THIS IS MY FAMILY'S PRIMARY VEHICLE AND I REGULARLY DRIVE MY 6 AND 11 YR OLD CHILDREN AROUND IN THIS VEHICLE. WE ALSO TRAVEL THE HIGHWAY AND 4 LANE SUSPENSION BRIDGE EXTENSIVELY. LOSING THESE BASIC SYSTEMS COULD RESULT IN A LIFE THREATENING SITUATION FOR ME AND MY FAMILY. I HAVE SEEN COMPLAINTS ON THE INTERNET DATING BACK TO DECEMBER 2016 AND THE PROBLEM IS STILL OCCURRING. THE VEHICLE WAS IN PROPER WORKING CONDITION, NO MAJOR PROBLEMS PRIOR, AND WELL BELOW THE MILEAGE EXPECTED FOR A VEHICLE OF THIS AGE WHEN THE ISSUES OCCURRED. I DON'T TRUST IT NOW.

Jan 15, 2020

SUSPENSION,SEATS

1 complaint

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBERS: 19V435000 (SUSPENSION) AND 19V651000 (SEATS). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE VEHICLE WAS TAKEN TO RIVERTOWN FORD (1680 WHITTLESEY RD, COLUMBUS, GA 31904, (706) 653-7420) AND THE CONTACT WAS INFORMED THAT PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND DID NOT ASSIST. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

Dec 06, 2019

STEERING,POWER TRAIN,ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

VEHICLE LOSES ACCELERATION, STALLS AND SHAKES WHEN AT A STOP. JERKS WHEN BACKING UP. VEHICLE HAS BEEN TO FORD TWO TIMES. FIRST TIME REPLACED THROTTLE, AND SECOND TIME UNABLE TO DUPLICATE ERROR. CURRENTLY WILL BE PICKING UP VEHICHLE FROM SHEEHY FORD ASHLAND IN VA. THIS IS EXTREMELY UNSAFE

Oct 29, 2019

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

1 complaint

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. WHILE TRAVELING ON THE HIGHWAY AT AN UNKNOWN SPEED WITH THE CRUISE CONTROL ENGAGED, IT SUDDENLY DISENGAGED ON ITS OWN. THE FAILURE CAUSED THE VEHICLE TO BRAKE ON ITS OWN AND SWERVE FROM SIDE TO SIDE. SAYVILLE FORD (5686 SUNRISE HWY, SAYVILLE, NY 11782, (855) 561-1191) STATED THAT THE LEASING MILEAGE LIMIT WAS EXCEEDED, BUT THEY WOULD NOT COVER THE COSTS. THE MANUFACTURER PROVIDED THE SAME INFORMATION AS THE CONTACT. THE CONTACT ALSO MENTIONED THAT THE BATTERY EXPLODED, BUT THE DEALER DISMISSED THE CONCERNS AND STATED THAT THE VEHICLE WAS NOT COVERED UNDER WARRANTY. THE FAILURE MILEAGE WAS 50,000.

Oct 07, 2019

STEERING,STRUCTURE,UNKNOWN OR OTHER

1 complaint

PAINT ON THE HOOD IS BUBBLING, STEERING FEELS LOSE, AND THE INSTRUMENT PANEL CRACKED DO TO COLD TEMP....CONTACTED FORD THEY DIA OT HELP OR DID NOT CAR

Sep 16, 2019

POWER TRAIN,UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM

1 complaint

TAKATA RECALL AFTER PURCHASING 2017 EXPLORER NOTICED SEVERE HEADACHES, DIGESTION PROBLEMS, DROWSINESS, DIFFICULTY FOCUSING DUE TO CARBON MONOXIDE ENTERING THE CABIN. TOOK IT TO THE DEALER FOR A RECALL BUT DOESN'T SEEM LIKE THAT THEY SOLVED THE ISSUE. ALSO NOTICED A RUMBLING SOUND UNDERNEATH THE VEHICLE WHEN TURNING LEFT UNDER ACCELERATION, FEELING LIKE A TRANSMISSION PROBLEM. WOULD NEVER EXPECT SOMETHING LIKE THIS TO OCCUR ON A $47K CAR WITH ONLY 30K MILES.

Aug 12, 2019

ELECTRICAL SYSTEM,SERVICE BRAKES

1 complaint

WHILE DRIVING TO WORK, WHILE THE VEHICLE WAS IN MOTION, I HEARD A LOUD POP SOUND, ENGINE BEGAN TO SMOKE. HAD VEHICLE TOWED IN TO LOCAL FORD DEALERSHIP WHICH INDICATED BAD CELL IN MANUFACTURERS BATTERY CAUSING IT TO BLOW AND SPRAY BATTERY ACID ALL OVER ENGINE COMPONENTS AT 26,127 MILES. DEALERSHIP DID NOT FOLLOW PROPER PROCEDURE WHEN REPLACING BATTERY AND LEFT ACID ON ENGINE AND COMPONENTS. BATTERY ACID HAD EATEN THROUGH BRAKE SYSTEM COMPONENTS, WIRING AND CAUSED SEVERE CORROSION UNDER HOOD. BY NOT ADDRESSING THE SAFETY CONCERN WHEN CONFRONTED AND DURING MULTIPLE VISITS AND PHONE E CALLS, BRAKE SYSTEM ABS FAILED CAUSING A FRONT END COLLISION BY SLAMMING INTO ANOTHER CAR IN THE INTERSTATE RESULTING FROM BRAKE SYSTEM FAILURE.

Jul 07, 2019

Crash: 1

STEERING,SUSPENSION,AIR BAGS

1 complaint

VEHICLE HAS AN NHTSA RECALL NOTICE#:19V435 AND A FORD ISSUED RECALL#:19S17 WHICH INDICATES AS FOLLOWS: RECALL DESCRIPTION: REAR SUSPENSION TOE LINK REPLACEMENT. RISK TO SAFETY: A FRACTURE OF A REAR TOE LINK SIGNIFICANTLY DIMINISHES STEERING CONTROL, INCREASING THE RISK OF A CRASH! I HAVE CONTACTED 3 DIFFERENT DEALS IN MY AREA (ECINO, CA, 91316) ALL SAID THAT THE REPLACEMENT PARTS ARE CURRENTLY UNAVAILABLE. IN ADDITION, ON THURSDAY, JUNE 27TH, 2019 I HAVE CONTACTED FORD MOTOR COMPANY TO SEE IF THE ISSUE CAN BE RESOLVED BUT I GOT THE SAME ANSWER. THEY SAID I HAVE TO WAIT UNTIL THE PARTS ARE AVAILABLE AND THEY ARE CURRENTLY BACK ORDERED WITH NO ESTIMATED TIME FOR THE ISSUE WITH THE VEHICLE CAN BE RESOLVED. THEY HAVE ASKED ME IF I WOULD LIKE FORD MOTOR COMPANY TO "LEMON" THE VEHICLE AND BUY IT BACK, I REPLIED: "ABSOLUTELY YES". THEY HAVE OPENED A CASE#: [XXX] I AM SERIOUSLY WORRIED FOR MY LIFE WHEN DRIVING THE FORD EXPLORER. I SUFFER FROM UNDERSTEERING WHENEVER I ATTEMPT A LEFT OR RIGHT TURN. AT SPEED OVER 40 MPH, THE VEHICLE WILL START SHAKING GIVING ME A SENSE OF ALMOST NO GRIP TO THE ROAD. IN ADDITION, I CONSTANTLY HAVE THE "FRONT AIRBAG" LIGHT ON (SEE PICTURE ATTACHED) THE DASHBOARD, BOTH WHEN VEHICLE IS IN MOTION & STATIONARY. THIS ISSUE HAPPENED BEFORE AND I TOOK THE CAR TO A FORD DEALER TO RESOLVE THE ISSUE (THE SERVICE TECH SAID THAT THE SENSOR WAS MALFUNCTIONED AND IN A CASE OF AN ACCIDENT, "FRONT AIRBAG" MIGHT NOT DEPLOY!!! THIS IS ABSOLUTELY ABSURD. I HERE BY CERTIFIE THAT MY VEHICLE IS SERVICED ON TIME (SEE PICTURE ATTACHED) AND CURRENTLY HAS 29,492 MILES ON IT (SEE PICTURE ATTACHED). I AM NOT SURE WHAT IS NHTSA PART IN ALL OF THIS, BUT IF YOU CAN HELP ME DEAL WITH FORD MOTOR COMPANY IN RESOLVING THESE ISSUES AND GET RID OF THIS VEHICLE, L WILL BE VERY PLEASED AND APPRECIATIVE. RESPECTFULLY, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT

Jun 28, 2019

STEERING,UNKNOWN OR OTHER,ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

I WAS STUCK AT A STANDSTILL IN TRAFFIC ON A CITY HIGHWAY WITH MY FAMILY ON FATHER'S DAY WHEN THE DASH LIT UP WITH MULTIPLE WARNINGS SUCH AS "STEERING LOSS STOP SAFELY," "SERVICE ADVANCETRAC," "STABILITY CONTROL OFF," AND "HILL START ASSIST NOT AVAILABLE." I WAS NOT MOVING AND COULD NOT UNDERSTAND WHAT HAPPENED. NO ONE WAS INJURED AND THE VEHICLE'S POWER STEERING FAILED. THE VEHICLE WAS NOT OVERHEATING. ROADSIDE BROUGHT THE VEHICLE TO A NEARBY DEALER. EVENTUALLY, TWO DAYS LATER, THE COMPUTER SAID WE NEEDED A NEW STEERING COLUMN (I THOUGHT A STEERING COLUMN SHOULD LAST THE LIFE OF THE VEHICLE...). THERE WERE NO WARNING SIGNS, NO LEAKS, AND NO STRANGE NOISES. OF COURSE, I WAS PAST MY WARRANTY. PRETTY HEFTY BILL. THERE IS AN NEW RECALL FOR A REAR SUSPENSION PROBLEM THAT WAS ISSUED JUST DAYS EARLIER.

Jun 21, 2019

POWER TRAIN,UNKNOWN OR OTHER,ENGINE

1 complaint

THE CAR LURCHES FOR THE FIRST 40-50 FEET AT SLOW SPEEDS WHILE APPLYING MINIMAL PRESSURE ON THE GAS PEDAL. IT HAPPENS THE INITIAL TIME PUTTING IT IN DRIVE AFTER EACH ENGINE START, REGARDLESS OF PUTTING IT IN REVERSE FIRST OR NOT. IT USED TO ONLY HAPPEN AFTER EVERY FEW STARTS, BUT HAS PROGRESSED TO EVERY SINGLE TIME NOW AND SOME CAN BE VERY AGGRESSIVE. THE DEALERSHIP HAS ATTEMPTED TO FIX THE ISSUE 5 TIMES NOW, WITH THE 5TH TIME RESULTING IN THEM SAYING IT IS A "NORMAL CHARACTERISTIC" OF THE VEHICLE, WITHOUT BEING ABLE TO EXPLAIN WHAT IS CAUSING IT. I WAS TOLD BY THE LOCAL SERVICE MANAGER THAT HE "DOESN'T KNOW WHY IT IS DOING IT, BUT IT'S NORMAL." HE THEN PROCEEDED TO COMPARE THE CHARACTERISTIC TO SOMEONE POORLY RELEASING THE CLUTCH ON A MANUAL VEHICLE AND AGAIN, STILL CLAIMING THAT EVERYTHING IS PERFECTLY NORMAL.

Apr 22, 2019

ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

1 complaint

I WAS DRIVING ON THE HIGHWAY AND MY CAR STARTED SHAKING AND SOUNDING DIFFERENT. THE VIBRATIONS KEPT GETTING WORSE. THEN I WAS TRYING TO ACCELERATE AND MY SPEED WAS GOING DOWN. I COULDN'T GET MY SUV TO GET ANY SPEED AT ALL IT GOT ALL THE WAY DOWN TO ZERO MPH AND I HAD TO COAST TO THE NEAREST PARKING LOT. THE LIGHT ON MY DASH SAID TERRAIN MANAGEMENT SYSTEM FAILURE. LUCKILY THERE WEREN'T ANY CARS BEHIND ME AS IT WAS AT NIGHT TIME. I TURNED MY CAR OFF AND ON AGAIN AND TRIED TO RESTART THE COMPUTER WITH NO LUCK. THE OWNERS MANUAL SAYS TO RECYCLE THE KEY AND TRY AGAIN. MY CAR IS PUSH BUTTON START SO THAT WASN'T AN OPTION. I THEN LOOKED ON GOOGLE TO FIND THE PROBLEM AND SAW THERE WERE MULTIPLE ISSUES FROM MULTIPLE PEOPLE THAT HAD THE EXACT SAME EXPERIENCE. I HAD IT TOWED TO THE DEALER TODAY AND THEY SAID IT WAS THE THROTTLE BODY HAD WENT BAD. MY SUV ONLY HAS 40,000 MILES ON IT.

Aug 16, 2018

STEERING,WHEELS,UNKNOWN OR OTHER

1 complaint

TIRES THAT CAME WITH VEHICLE HAVE CHUNKS OF TREAD PEELING OFF /CUTTING FROM NORMAL DRIVING OF 9100 MILES AND 11 MONTHS. THIS PRESENTS SEVERAL HAZARDS SUCH AS VEHICLE STABILITY, TRACTION AND POTENTIAL BLOWOUT / ROLLOVERS OTHER SIZES THESE SAME HANKOOK VENTUS S1 NOBLE2 HAVE ALREADY BEEN RECALLED DUE TO SIMILAR FAILURES. THESE ARE 255/50 R 20 SIZE.

Jun 13, 2018

ENGINE AND ENGINE COOLING,FUEL/PROPULSION SYSTEM

1 complaint

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. WHILE DRIVING VARIOUS HIGH SPEEDS OR WHILE THE VEHICLE WAS IDLING, THERE WAS A ROTTEN EGG ODOR ENTERING THROUGH THE VENTS OF THE VEHICLE. THE ODOR WAS PRESENT WHILE THE AIR CONDITIONER WAS IN USE. THE CONTACT STATED THAT THE FOUR OCCUPANTS IN THE VEHICLE EXPERIENCED BREATHING DIFFICULTY, LIGHT HEADACHES, NAUSEA, AND BLURRED VISION, WHICH REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TAKEN TO GRIECO FORD (3000 S FEDERAL HWY, DELRAY BEACH, FL 33483), BUT THE CAUSE OF THE FAILURE WAS UNDETERMINED. THE DEALER STATED THAT THE ODOR FAILURE WAS RELEVANT TO POLICE VEHICLES AND NOT NON-POLICE SUVS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 9,000.

Apr 03, 2018

SUSPENSION,ENGINE

1 complaint

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 30 MPH, THE CONTACT HEARD AN EXPLOSION COMING FROM THE FRONT PASSENGER SIDE OF THE VEHICLE. THE VEHICLE THEN STALLED WITHOUT WARNING. IN ADDITION, THE FRONT PASSENGER SIDE CONTROL ARM DETACHED, WHICH CAUSED THE PASSENGER TIRE TO EXPLODE. THE VEHICLE WAS TOWED TO A TOWING LOT. THE VEHICLE WAS LATER TAKEN TO PENSKE FORD COLLISION CENTER (8970 LA MESA BLVD, LA MESA, CA 91942, (619) 464-7777) WHERE IT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THEY WERE NOT RESPONSIBLE FOR THE FAILURE AND ADVISED THE CONTACT TO "WORK IT OUT THE BEST HE COULD". NO FURTHER ASSISTANCE WAS OFFERED. THE APPROXIMATE FAILURE MILEAGE WAS 11,000.

Feb 06, 2018

ELECTRICAL SYSTEM,SERVICE BRAKES,ENGINE

1 complaint

DRIVING DOWN A DIRT TRAIL FROM A MOUNTAIN OUTLOOK THE CARS ELECTRICAL SHUT OFF. WE HAD NO CONTROL OF BRAKES, OR ANYTHING BUT STEARING. NOT TO MENTION WE WERE PICKING UP MAJOR SPEED DOWN A MOUNTAIN, AND BOUNCING EVERYWHERE. WE HAD TO SWERVE BACK AND FORTH, HITTING BUSHES AND SEMI DRIVING UP THE SIDE OF THE MOUNTAIN TO TRY AND SLOW DOWN. OUR WHOLE FAMILY WAS IN THE CAR, INCLUDING A TWO MONTH OLD AND A THREE YEAR OLD. THE ONLY WAY WE GOT IT TO WORK AGAIN WAS SLAMMING THE SHIFTER INTO NEUTRAL AND THEN PUSHING THE RESTART BUTTON, BUT IT WAS PROBABLY JUST OUR PRAYERS THAT GOT THE CAR TO TURN BACK ON AND GIVE US BRAKE CONTROL AGAIN. I'M AFRAID TO DRIVE MY CAR IN FEAR OF IT HAPPENING AGAIN.

Oct 24, 2017

SEAT BELTS,SERVICE BRAKES

1 complaint

TL* THE CONTACT OWNS A 2017 FORD EXPLORER. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT WAS INVOLVED IN A FRONT END COLLISION WITH A WALL DUE TO BRAKE FAILURE. THE CONTACT STRUCK THE STEERING COLUMN BECAUSE THE SEAT BELT FAILED TO PROPERLY RESTRAIN HER. THE VEHICLE WAS TAKEN TO THE CONTACT'S RESIDENCE AND THEN TO THE GORNO FORD DEALER, WHERE IT WAS DEEMED DESTROYED. A POLICE REPORT WAS NOT FILED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THERE WERE NO RECALLS ON THE VEHICLE. THE CONTACT SUFFERED FROM MODERATE CHEST PAIN FROM STRIKING THE STEERING COLUMN AND REQUIRED MEDICAL ATTENTION. THE FAILURE MILEAGE WAS 3,694.

Jul 07, 2017

Crash: 1

Injuries: 1

VEHICLE SPEED CONTROL,FUEL/PROPULSION SYSTEM

1 complaint

LAST NIGHTS AS I DROVE MY NEW 2017 EXPLORER OFF THE LOT WITH ONLY 11 MILES ON IT, I DROVE ON SURFACE STREETS AND THEN ONTO THE HIGHWAY. AFTER I GOT UP TO 65 MPH THE EXPLORER STARTED TO LOSE ACCELERATION ON THE HIGHWAY. I HAD TO GET OFF AT THE NEXT EXIT AND THEN HAD GREAT DIFFICULTY GETTING THE CAR TO MOVE FROM 0 TO 30 MILES PER HOUR TO GET BACK TO THE DEALERSHIP USING THE SIDE STREETS. I NOW HAVE A LOANER CAR AND I WAS FIRST TOLD IT COULD BE THE ELECTRONIC THROTTLE BODY, AND THEN AFTER A HOOKUP TO THE COMPUTER WAS TOLD IT WAS IN TRANSPORT MODE - HOWEVER NOTHING ON THE INSTRUMENT PANEL REGISTERED ANY PROBLEMS. I HAD TEST DRIVEN THE CAR ON SATURDAY 3/18/17 USING BOTH SURFACE STREETS AND HIGHWAYS, AND LAST NIGHT (3/20/17) I WAS ABLE TO GET IT UP TO SPEED ON THE HIGHWAY AGAIN. THE EXPERIENCE WAS VERY SCARY AS I HAD TO MANEUVER OUT OF TRAFFIC TO GET OFF THE HIGHWAY AT SPEED BELOW 40 MPH UNTIL I COULD GET TO THE SIDE STREETS.

Mar 21, 2017

ELECTRICAL SYSTEM,EXTERIOR LIGHTING

1 complaint

ON 09/15/16 WE PURCHASED A 2017 FORD EXPLORER LIMITED FROM SUPREME FORD OF SLIDELL, LA. TWO WEEKS AFTER HAVING THE SUV, WE NOTICED THE RIGHT TAIL LIGHT WAS NOT WORKING AT TIMES. ON 11/16/2016, WE DROVE THE VEHICLE BACK TO THE DEALERSHIP TO REPAIR THE LIGHT. WHEN THE SALES MANAGER DROVE THE SUV TO THE SERVICE DEPARTMENT THE REAR RIGHT TAILLIGHT WAS WORKING.. BUT WHEN THE SERVICE MANAGER LOOKED AT THE SUV, THE LIGHT WAS WORKING. BUT WHEN WE STARTED BACK TO DENHAM SPRINGS, LA, THE RIGHT TAILLIGHT STARTED ACTING UP AGAIN. I TOOK SEVERAL VIDEOS OF THE LIGHT RANDOMLY GOING OFF AND ON THE TRIP BACK HOME WITH MY IPHONE. I ATTACHED VIDEO OF THE LIGHT, I EDITED IT TO A SMALLER SIZE AND EMAILED BACK TO THE DEALERSHIP. ON 11/17/16 WE RECEIVED A REPLY FROM THE SERVICE MANAGER STATING; THANK YOU FOR TAKING THE TIME TO VIDEO AND SEND IT TO US REGARDING THE TAILLAMP CONCERN YOU ARE HAVING WITH YOUR 2017 EXPLORER, THE NEXT TIME THE CONCERN DISPLAY ITSELF CONSISTENTLY, A RENTAL AT OUR EXPENSE FOR A DAY TO SEE IF WE CAN ISOLATE THE CAUSE. [XXX] SERVICE MANAGER SUPREME FORD SLIDELL [XXX] [XXX] I REPLIED TO THE DEALERSHIP; [XXX], THE NEW 2017 FORD EXPLORER LIMITED STILL HAS A PROBLEM WITH THE RIGHT TAIL LIGHT INTERMITTENTLY WORKING ABOUT %50 OF THE TIME. I DO NOT THINK THERE WILL BE A TIME WHEN THE TAIL LIGHT WILL "CONSITTANTLY" GO OUT... THIS PROBLEM NEEDS TO BE REPAIRED ASAP BEFORE SOMEONE IS KILLED IN AN AUTOMOBILE ACCIDENT... THE VIDEO CLIP I SENT YOU IS JUST A SAMPLING OF THE TAIL LIGHT INTERMITTENTLY GOING OUT DURING OUR DRIVE HOME TO DENHAM SPRINGS... I AM CONCERNED WITH DRIVING THE "LEMON VEHICLE" AND BELEIVE THAT FORD NEEDS TO REPLACE THE "LEMON VEHICLE" WITH A PROPER WORKING NEW 2017 FORD EXPLORER LIMITED, WITH A ADAPTIVE CRUISE CONTROL AS THE SALESPERSON STATED THE VEHICLE HAD. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Nov 28, 2016

2017 FORD Explorer Problems & Complaints

Complaints by Component

Frequently Asked Questions

How many problems does the 2017 FORD Explorer have?

What are the most common problems with 2017 FORD Explorer?

Where does this 2017 FORD Explorer problem data come from?

Other Years - FORD Explorer

Other FORD Models

Similar Brands