2021 FORD Explorer Problems & Complaints
Real owner complaints and problems reported to the National Highway Traffic Safety Administration (NHTSA). View common issues by component.
336
Complaints Reported
Complaints by Component
POWER TRAIN
69 complaints
The contact owns a 2021 Ford Explorer. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 23V675000 (Power Train); however, the repair failed to prevent a failure shortly after the vehicle was serviced. The contact stated that after shifting from reverse(R) to drive(D), there was an abnormal grinding sound coming from the vehicle before the vehicle lost automotive power. The vehicle was towed back to another local dealer, Sutton Ford (21315 Central Ave, Matteson, IL 60443); where it was diagnosed with a fractured rear axle bolt. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 77,000.
Dec 18, 2025
The contact owns a 2021 Ford Explorer. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate. In addition, the vehicle jerked aggressively, and the engine idled roughly. No warning lights were illuminated. The vehicle was towed to the contact's residence. The vehicle was taken to the dealer, where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train). The contact inquired if the failure was the result of the recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 97,954.
Nov 20, 2025
We received notification from Ford that there is a "rear axle bolt fracture" possible on our 2021 Ford Explorer and noted we were to contact our dealer to address. However when I reached out to the dealership (and then subsequently to Ford Customer Service) I was told that the issue was being treated on an "extended warranty" basis. We would recognize the issue when we noticed severe vibration and lost of mobility in the vehicle and that putting it in Park would not keep the vehicle from rolling. Based on those calls, my wife could be left on the side of the road, involved in a fatal accident (to her or others) etc., instead of addressing the issue as a preventive measure. In addition, nothing in our coversations or in their notice involved the cost to us for additional damage to the vehicle, towing or a rental car (as the dealership said they wouldn't even be able to order the bolts until the fracture occurred and they had the vehicle in their shop. The service code for this defect is 24N01. As of this date we have not experianced this issue but am trying to avoid it occurring since it is a known defect by Ford.
Nov 05, 2025
There was no lights on the dash but the transmission was shifting very hard when slowing down. I took it to the dealer for service, but the dealer says the transmission is full of debris and needs a full replacement. When slowing down it was causing the vehicle to buck forward very hard advancing it forward and causing me the driver to feel forward force from the harsh bucking of the transmission.
Oct 01, 2025
Approximately 6 weeks ago, while driving at 30 -35 mph in residential area, vehicle started lurching/jolting, took to local dealership, nothing found, reported to Customer Service, instructed to write to FMC Consumer Affairs and am waiting on reply.
Sep 28, 2025
+ 64 more complaints for this component
UNKNOWN OR OTHER
47 complaints
The sliding roof mechanism for the sunroof failed and droops into the backseat impairing vision. This can be triggered accidentally while driving causing zero rear visibility. This is part of the sun roof that is the shade keeping the sun out of the car. With extremely little use on my 2021 ford explorer this mechanism has failed causing this dangerous malfunction. I found may posts in Facebook describing this same issue. [XXX] There’s just one example of many people having this issue. There’s component was taken to the Ford dealership where I was provided a verbal quote of more than $4,000 to fix, which is not feasible. There were no warning signs. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Dec 16, 2025
The sunroof shade is sagging. It broke from one day to the next, and it’s blocking my rear view.
Dec 15, 2025
Sunshade is sagging. For the 2nd time.
Dec 07, 2025
Panaromic sunroof blind became lose and is sagging, causing an unsafe driving experience, making it difficult to see out rear view mirrors.
Dec 03, 2025
The sunroof sunshade snapped a clip off and now hangs down blocking the rear view. It is impossible to see out the back window. I have read on multiple sites that this is happening to many of these SUVs and it's an extremely expensive and difficult fix. It's very dangerous and I won't even let my girlfriend drive it anymore.
Dec 01, 2025
+ 42 more complaints for this component
BACK OVER PREVENTION
22 complaints
The contact owns a 2021 Ford Explorer. The contact stated that upon shifting into reverse, the rearview camera failed to display an image. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 25V315000 (Back Over Prevention); however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 36,000.
Jun 02, 2025
The contact owns a 2021 Ford Explorer. The contact stated that while reversing, the back over prevention camera screen display was inoperable. The contact stated that a blue screen was displayed creating a visibility hazard for the driver. The cause of the failure was not yet determined. The contact was informed that the VIN was not included in NHTSA Campaign Number: 23V342000 (Back Over Prevention). The vehicle was not repaired. The contact stated that the vehicle had experienced the failure listed in the recall. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 34,600.
Jul 10, 2024
The contact owns a 2021 Ford Explorer. The contact stated while attempting to shift into reverse, the contact became aware that the rear-view camera showed a blue screen. There was no warning light illuminated. The dealer was contacted; however, the vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 32,000.
Jun 11, 2024
The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V342000 (Back Over Prevention) however, the part to do the recall repair was not yet available. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the camera intermittently failed, causing a visibility hazard for the driver. The failure mileage was 60,000. VIN tool confirms parts not available.
Feb 12, 2024
The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V342000 (Back Over Prevention) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the back-over prevention camera intermittently failed to operate as needed while in use. The failure mileage was approximately 30,000. VIN tool confirms parts not available.
Feb 07, 2024
+ 17 more complaints for this component
ENGINE
15 complaints
The contact owns a 2021 Ford Explorer. The contact stated that the VIN was included in NHTSA Campaign Number: 24V598000 (Engine). The local dealer was contacted and declined to complete the recall repair. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The contact had not experienced a failure.
Dec 16, 2025
My explorer is only 4 years old and it suddenly suffered catastrophic engine failure due to low engine oil. The engine started knokcing and clattering BEFORE any warning lights came on the dash. This could also be due to premature bearing failure which is common in the 3.0 ecboost engines.
Dec 02, 2025
The contact owns a 2021 Ford Explorer. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as needed and then lost motive power. The engine made ticking sounds, and the vehicle was running rough. No warning light was illuminated. The contact coasted the vehicle into the driveway. The vehicle was towed to the dealer, who discovered that the timing chain, spark plugs, and intake valves were fractured. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 80,000.
Sep 09, 2025
We were driving the vehicle when we experienced a sudden loss of power and acceleration. We also noticed odors of gas. We took it to a Ford authorized dealership and they said it was due to antifreeze in the oil from what they said was a leaking water pump. They recommended a new engine due to the difficulty of changing the internal water pump and the fact it leaked antifreeze into the engine oil, possibly damaging the engine itself. This was the explanation for the fault codes, random gas odors, and loss of power. It was explained this was normal when the sensors detect something wrong with the oil in the engine. Estimated cost provided by the dealership was $11,000 to replace the engine.
Mar 25, 2025
I had complete engine failure on my 2021 115,000 mi Ford Explorer ST. The truck was only 3 years old. I heard a knocking noise and pulled over. Throughout the summer smoke had been coming out of the exhaust pipe every time I turned on the car before work. There was a cloud of smoke. A week before the engine failure I had the vehicle in the ford shop. They said everything was fine. I towed the vehicle to Currie Ford in Frankfort and they stated that there was catastrophic engine failure. Nothing could be done but I needed to put a new $12,000 engine in a $63,000 car. They said the warranty did not cover nor do I have any recourse. The safety of my family was placed at risk., I was travelling with my family, my wife, son, daughter, nephew who is [XXX] old and niece who is [XXX] . It left us stranded. There were no warnings. The dealership inspected the car a week before and said it was good to go. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mar 07, 2025
+ 10 more complaints for this component
STRUCTURE
14 complaints
The contact owns a 2021 Ford Explorer. The contact stated that there was a 15x3/4-inch strip on the B-pillar trim of the driver's side rear door that was detaching from the vehicle. The vehicle was taken to the dealer, who attempted to use adhesive to secure the trim piece; however, the temporary repair failed to fix the vehicle. The dealer determined that the entire B-pillar trim needed to be replaced. The vehicle was not repaired. Additionally, the contact became aware that the B-pillar trim on the passenger's side rear door had started to detach. The contact informed the manufacturer of the failure. The contact was informed that the VIN was not included in NHTSA Campaign Number: 25V347000 (Structure). The manufacturer advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 65,000.
Aug 27, 2025
The contact owns a 2021 Ford Explorer. The contact stated that upon inspecting the vehicle, the contact noticed that there was a gap between the body and the frame on the passenger's side of the vehicle. The vehicle was not diagnosed or repaired by a dealer or an independent mechanic. The manufacturer was notified of the failure, and a case was filed. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 74,000.
Jun 27, 2025
The chrome on the window switch on the passenger side is peeling and cut my finger while using it.
Apr 13, 2025
I was backing out of my driveway and a whoosh of water came pouring into my trunk from my roof of my car. When I took it to the Ford dealership they took the headliner down and found that the drains for my sunroof were clogged and caused the leak. They found that the headliner had mold growing on it. This is currently not a recall issue yet but I believe it should be or should be considered a default from Ford, (my warranty expired a couple months earlier). After speaking with the maintenance manager at Ford, I have been informed that it is not uncommon that the sunroof drains get clogged and this is something that should be checked or cleaned out periodically. With that being said- my 3 year old vehicle has only been maintained at a Ford dealership during its life. I go every 3-4 months and this has never been checked or cleaned out. My vehicle has been at the dealership for 3 months now because the parts are on back order. When I spoke with the dealership on 12/18 I was told there were 16 headliners on order, but when I checked back in January (a month later) there were 437 on order. This seems to be an issue with more and more of these vehicles. This is a dangerous situation because I do not know how long the mold has been growing in my vehicle and could cause health issues with me or my kids.
Feb 04, 2025
The contact owns a 2021 Ford Explorer. The contact stated that the power liftgate failed to close as needed. The contact was able to manually close the liftgate. Additionally, the roof was leaking near the sunroof and roof rails. There were no warning lights illuminated. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 58,000.
Sep 25, 2024
+ 9 more complaints for this component
ELECTRICAL SYSTEM
14 complaints
The contact owns a 2021 Ford Explorer. The contact stated that while his wife was driving and was at a traffic light, the light turned green and the accelerator pedal was depressed; however, the vehicle stalled. The contact stated that there was no warning light illuminated. The contact stated that the instrument cluster was dark, and the vehicle failed to restart. The contact stated that his wife waited for approximately 15 minutes in the middle of the road. The contact’s wife was able to restart the vehicle and drove a local dealer. The vehicle had experienced the failure in November 2024 and the same dealer replaced the battery and replaced all four tires. The contact stated that the vehicle was diagnosed, and the dealer determined that the 12-Volt battery needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 30,000.
Dec 06, 2024
The contact owns a 2021 Ford Explorer. The contact's wife stated that while driving at an undisclosed speed, the vehicle lost motive power with a system shut-down message displayed. The contact also stated that the vehicle inadvertently shifted into park. The vehicle was able to restart after 30 minutes. The vehicle was taken to the dealer where it was diagnosed and determined that the tires had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 30,469.
Nov 18, 2024
The contact owns a 2021 Ford Explorer. The contact stated that occasionally the front driver’s and front passenger’s side windows failed to respond while depressing the switch. The contact stated that the failure was recurring and was previously repaired by the dealer. The vehicle was taken back to the same local dealer and remained at the dealer for the repair. Additionally, the contact stated that the local dealer was unable to duplicate the failure. The manufacturer was made aware of the failure. The failure mileage was approximately 18,600.
Sep 30, 2024
Been dealing with this backup camera blue screen for the last year. I pay too much money for this not to be working. Someone came out yesterday to fix it but it’s still doing the same thing.
Sep 28, 2024
The contact owns a 2021 Ford Explorer. The contact stated that while driving at an undisclosed speed, the audio connection failed to function as intended. The contact stated that there was no audio power. The vehicle was taken to the dealer and the contact was informed that the radio audio connection was in the rear hatch of the vehicle and that water had been leaking into the rear hatch of the vehicle. The vehicle was not repaired. The manufacturer was made aware of the failure and agreed to assist with sixty-five percent of the repair cost. Additionally, the contact was advised to report the failure to the NHTSA Hotline. The failure mileage was 33,000.
Mar 22, 2024
+ 9 more complaints for this component
VISIBILITY/WIPER
10 complaints
The shade that covers the moonroof has fallen off the tracks (or something) and it's sagging down from the headliner. There wasn't a snapping or breaking sound, I just went to open it and it sagged instead of sliding back under the headliner like it should. The car is only 4 years old, we bought it new, and we hardly ever use this feature, so it hasn't received a lot of use. With the shade sagging down (it won't go back into place) it blocks the view of the rear window, which makes it a safety hazard. Apparently it's not covered by my warranty, and will be around $1,800 to fix. My car is at the dealership right now and they just told me it's not covered. This is very dangerous because it also blocks the view of my children in the back seat, and most of the rear window. I just googled how to fix it, and it seems like this is a known issue that many others are having. There was no warning lights or messages about this failure. It first happened on October 11, 2025. Note: It's still at the dealership, and I need to pick it up after work, so I don't have a photo to include. I apologize.
Oct 21, 2025
Sunroof shade loose / sagging when retracting. Issue is caused by a worn sunshade spring. When retracted, the sunroof shade fabric sags to the degree that it blocks / obscures the driver's view of the back window and activity to the rear of and/or behind the vehicle. An internet search shows that this in a known / common issue with Explorers.
Sep 26, 2025
I was driving down the road and heard a loud pop and it sounded like a golf ball hit my door. I immediately looked in my rear view mirror and was unable to see anything. After merging to the shoulder of the road and stopping safely I turned around and noticed that the headliner from my sun roof had broken and fallen and was blocking all view from my mirror.
Aug 11, 2025
While driving, the panoramic sunroof shade on my vehicle failed to retract properly, sagging down into the rear visibility area. The shade hangs low enough to completely block the view through the rearview mirror, significantly impairing my ability to monitor traffic behind me. This is a serious safety hazard, particularly when changing lanes, merging, or reversing. The issue also impacts rear passengers, as the drooping shade hangs down into the back seat area. This obstruction makes it difficult to check on passengers—especially children—while driving. There were no warnings before this failure occurred, and research shows that this problem is common among other owners, as documented in multiple online forums and complaint records. The shade appears to have a design flaw where the guide sliders or attachment points fail, causing it to sag into the driver’s line of sight. This failure should not happen on a safety-critical component affecting visibility. Given the frequency of reports and the direct impact on driver awareness, a recall or mandatory repair campaign should be issued to address this defect in all affected vehicles.
Aug 11, 2025
My vehicle is equipped with a panoramic sunroof, furthermore the panoramic sunroof has a sliding screen to block out the sun when the owner prefers to block the sun. The issue is with the panoramic sunroof screen, this particular screen also slides on rails below the glass window from the panoramic sunroof. The sliders from the screen part seem to break and cause the screen to sag downward blocking the view from the rear view mirror. In which case it’s a safety hazard for the passengers and public due to limited visibility. Furthermore, it also blocks the view of monitoring the rear passengers in which in this case they are toddlers.
Aug 06, 2025
+ 5 more complaints for this component
ENGINE AND ENGINE COOLING
9 complaints
The contact owns a 2021 Ford Explorer. The contact stated that while driving approximately 30 MPH, the check engine warning light illuminated, and there was a burning odor coming from the vehicle. The contact pulled over and parked and allowed the vehicle to cool down before driving back to the residence. The vehicle was towed to the dealer and was diagnosed with coolant intrusion into the engine and the oil main bearings, causing engine failure. The contact was informed that the engine needed to be replaced. The contact received a notification of NHTSA Campaign Number: 24V635000 (Engine and Engine Cooling); however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was unknown.
Oct 17, 2025
The contact owns a 2021 Ford Explorer. The contact stated that while his wife was driving at an undisclosed speed, the driver heard an abnormal sound coming from the rear of the vehicle. The contact stated that the failure recurred while the vehicle was idle. Additionally, the contact stated that the driver had noticed an abnormal exhaust odor coming from the outside of the vehicle. The vehicle was taken to the dealer, where it was diagnosed that the catalytic converter had fractured at the welds location and needed to be replaced. The vehicle was not repaired due to cost. The vehicle was then taken to an exhaust system center, where it was being diagnosed. The vehicle was not repaired. The contact related the failure to Ford Campaign Number: 21E11. The manufacturer was not made aware of the failure. The failure mileage was approximately 89,000.
Jun 12, 2025
The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V635000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Apr 11, 2025
The contact owns a 2021 Ford Explorer. The contact stated that while driving approximately 40 MPH, the vehicle lost automotive power. The contact stated that there was an abnormal shaking and vibrating coming from the engine compartment. The vehicle was taken to a nearby mechanic to be diagnosed. The contact was informed that cylinders #3 and #4 had lost compression, and the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in NHTSA Campaign Number: 24V598000 (ENGINE). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 105,000.
Feb 14, 2025
The contact owns a 2021 Ford Explorer. The contact stated while coming to a stop, the vehicle stalled with an engine misfire. The contact stated there was a knocking sound coming from the engine with the check engine warning light illuminated. The vehicle was restarted; however, the failure recurred. The vehicle was taken to the dealer where it was diagnosed that valve springs in the engine cylinder needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and confirmed that the VIN was not included in NHTSA Campaign Number: 24V635000 (Engine and Engine Cooling). The contact was referred to the NHSTA Hotline for assistance by the manufacturer. The approximate failure mileage was 74,000.
Oct 31, 2024
+ 4 more complaints for this component
SEATS
7 complaints
Passenger second row (Captain's) seat is loose, shakes (sometimes violently) and rattles loudly when vehicle is moving (and seat is unoccupied).
Sep 22, 2025
The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V393000 (SEATS); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that while driving at various speeds, the rear passenger’s seat moved forward unintendedly. There was no warning light illuminated. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The approximate failure mileage was 80,000. VIN tool confirms parts not available.
Jul 08, 2025
The passenger 3rd row seat if the fold button is hit it can lock and pin a passenger. It wont release itself unless you try and hit the reset holding the 2 buttons simultaneously. Currently for safety reasons I taped that seats button and won't let anyone out in the 3rd row
Jun 23, 2025
The contact owns a 2021 Ford Explorer. The contact stated that the third-row seats were inoperable. The contact stated that the passenger’s and driver’s side seats were frozen in a semi-folded-down position and were not responding to the electronic control switch. The contact stated no warning light was illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the seat control unit needed to be replaced. The contact was advised by the dealer that the seat failure was a known failure; however, the vehicle was no longer under warranty. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was 40,438.
Feb 12, 2024
Front passenger seat overheated and caused 2nd degree burns
Mar 27, 2023
+ 2 more complaints for this component
POWER TRAIN,ENGINE
7 complaints
While our 2021 Ford Explorer with 47,000 miles to work the vehicle warning light came on stating the vehicle was overheated and shut down. We allowed the vehicle to cool for 20 minutes as recommended by the owners manual and then restarted the vehicle which immediately overheated again. We had the vehicle towed to the local dealer who diagnosed the issue as coolant in the oil forcing a replacement of the engine and coolant systems.
Jun 11, 2025
The vehicle has intermittent issues with bucking, running poorly, and not shifting properly. It results in several warning lights which will clear at random. The dealer has told us it needed a new alternator. The repair was made but the problem resurfaced again today. This is not a new issue as it has occurred many times before.
May 14, 2025
The contact owns a 2021 Ford Explorer. The contact stated that while driving 80 MPH, the power train warning light illuminated, and the vehicle stalled. The contact was able to exit the highway and the contact was able to pull over to the side of the road. The contact stated that upon turning off and restarting the vehicle, the vehicle operated as needed. The contact stated that the failure had been recurring while driving. The vehicle was taken to Express Care Automotive, where it was diagnosed that a valve in the engine had failed. The mechanic informed the contact that the engine needed to be taken apart for additional diagnostic testing. The mechanic informed the contact that the failure could be related to Ford Campaign Number: 24S55. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 80,000.
Jan 27, 2025
When driving or on neutral the vehicle shakes between 1000rpm-1500rpm. During driving or stationary you can feel the vehicle vibrating when in that rpm range. Under load the car does feel a bit hesitant and tampers acceleration. They're is a TSB 22-2377 which may be related to this issue as well.
Jan 02, 2025
My vehicle started to put up messages regarding going into power saver mode. The vehicle then said all wheel drive not available. After that electrical components started going unavailable such as power steering, brake assist, blind spot monitoring, cameras, and traction control. The vehicle then shut down while driving and all I could do was brake. When I attempted to restart the vehicle it did not restart. I jumped it and was able to safely pull it off the road. This is the 2nd time in three weeks this happened. Ford looked at the vehicle and tightened the battery cables. Then told me it was fine.
Mar 03, 2024
+ 2 more complaints for this component
VISIBILITY
6 complaints
The contact owns a 2021 Ford Explorer. The contact stated that while driving at approximately 25 MPH, the liner of the panoramic sunroof was opened and was sagging, which obstructed the view of the rearview mirror. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 38,800.
Nov 10, 2025
The contact owns a 2021 Ford Explorer. The contact stated that while driving at an undisclosed speed, the front driver’s door window independently rolled down. In addition, the contact stated that the failure had previously occurred with the front passenger’s and rear driver’s side windows. The contact stated that during the first failure the vehicle was repaired by the dealer and covered under warranty. After the second failure, the vehicle was repaired by an independent mechanic and the contact paid out-of-pocket. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 68,188.
Aug 15, 2025
The contact owns a 2021 Ford Explorer. The contact stated that while driving 55 MPH, the contact heard an abnormal sound, and the tempered stationary sunroof glass shattered without impact. The local dealer was contacted; however, the vehicle was not diagnosed or repaired due to the cost. The manufacturer was not made aware of the failure. The failure mileage was approximately 38,000.
Jan 06, 2025
The contact owns a 2021 Ford Explorer. The contact stated that the passenger’s side rear door glass fastener installed between the V-shaped glass and the door glass had fractured. The vehicle was taken to the dealer. The contact was informed that the passenger’s side rear door glass fastener needed to be replaced. The contact was informed that the repair could not be covered under warranty. The vehicle was repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 30,000.
Jan 24, 2024
The contact owns a 2021 Ford Explorer. That contact stated that the silver plastic strip on the driver's side power window switch had started peeling away, creating the potential for her to lacerate her finger. The vehicle was not taken to the dealer or an independent mechanic. After investigating the failure, the contact related it to Customer Satisfaction Program: 22B37, but the VIN was not included. The manufacturer was notified of the failure. The failure mileage was unknown.
Jun 29, 2023
+ 1 more complaint for this component
SERVICE BRAKES
5 complaints
Hi, i am concerned about the safety of my vehicle. i brought it to the attention of ford motor company and an authorized dealer that i am getting a parking brake warning on my dashboard. the authorized dealer inspected it, and said that the braking system is contaminated due to liquid spilling from the damaged cupholders. i communicated to them, that 1. the cupholders are clearly not strong enough to be placed over a critical component of the vehicle such as a braking system. 2. i think that this is a design flaw as there are normally drips and spills from having liquid in your car, especially in the designated place for it (cupholders). I should not be held liable for the repair to the braking system. they insisted this should be for my account, and if i decided not to fix it, it could lead to the entire braking system malfunctioning while the car is in motion or at a stand still. I am noting this with the department of transportation for investigation hopefully prior to an incident/accident taking place and the risk of a fatality, i have communicated to the dealer but they feel they have no accountability for this. while this may seem to be a cosmetic issue "just a cupholder", it is directly over a critical system of the car, and based on research i have done, i am not the only one with a broken cupholder in my ford explorer.
Aug 27, 2025
Part 573 Safety Recall Report 23V-675 The recall that is has been applied causes safety issues with the car when driving forward or in reverse. When putting the car into park the parking break auto applies. Now that is great however.. When putting the car into reverse or drive it does not release until the accelerator is applied. Now the problem is that the electric parking brake is delayed vs the acceleration causing the car to jerk forward or in reverse when the accelerator is applied. It acts like your trying to do a burn out holding down the break and it releases. This is not safe. A worker at the dealer almost rear ended a power pole in the parking lot because of this. My suggestion is to have the electric parking brake disengaged automatically when the car is put into drive or reverse. This will keep the protection of the electronic parking break being applied while in park and allowing smooth transition back to drive and reverse. Why has this issue been brushed under the rug..
Jul 30, 2024
On July 1, 2023, I had the vehicle parked on an incline with a trailer attached to the vehicle. The vehicle was in Park and the Parking Brake was set. As I attempted to unload the trailer, the vehicle started to move and rolled down the incline. I was on the trailer and was moving with the vehicle, I could have been injured but fortunately the vehicle rolled into a pile of topsoil before it could pick up too much speed. However, both the vehicle and trailer were damaged My safety was put at risk as the vehicle was moving without anyone in it. This occurred in my driveway but could have happened on a busy street. I still own the vehicle and it is available for inspection. There were no indications, warning lamps, etc. that would have notified me of the impending failure. I contacted Ford and they have been of little help. It took them 2-1/2 months to get me scheduled to have one of their field service engineers to inspect the vehicle. I was not allowed to talk to the field service engineer and that person did not attempt to duplicate the conditions which caused the failure. The report from Ford to me said they inspected the vehicle on a lift. They said they could not find a problem and said they will take no further action. They have been extremely uncooperative and do not seem the least concerned about the safety of the vehicle. I am concerned that the problem will recur and cause significant damage or injury so I take precautions whenever I park it.
Sep 15, 2023
I had a reputable after market brake system installed on my 2021 Ford Explorer ST at Holman Ford in Turnersville,NJ a couple years back. Since this time I have taken back the vehicle for my brakes being too spongy. I explained to the dealership that the brakes needed to be bleed again. The technician did not and adjusted the actuator on the brakes. Last year around the same time I had almost complete brake failure. This was do to the brakes having air in the lines and leaking from a fitting. The same concern I had from the beginning. The dealership fixed the problem and also added the parking brake software due to my vehicle only having one rear bolt in the subframe. Since this time, I have received numerous parking brake fault codes on my instrument cluster. The parking brake also disengages violently to the point where my vehicle lunges forward. It wasn’t until several days ago that my 2021 Explorer went back to the dealership for the parking brake issue and then saying my parking brake actuator broke apart. I have had nothing but issues with my brakes installed by the dealer and now I’m experiencing an issue caused from the software update.
Jun 26, 2023
loud popping metal sound from rear brakes as vehicle starts to move Ford has been contacted and replaced rear brake pads which made no difference. This problem started last August After Safety Recall 22S27 below is a link to videos with sound which clearly describe my safety concern https://www.dropbox.com/sh/a3iawirsizbc6iq/AAA3dgaCvZ9JcouFufKLLmGUa?dl=0
Feb 24, 2023
EXTERIOR LIGHTING
4 complaints
Adaptive Headlamps keep going out causing a safety issue.
Dec 17, 2025
vehicle low beam headlights went out all of the sudden. Would not come back on after car was turned off and restarted. Drove home with high beams on. Next day, just the driver side low beam came back on. Took to dealer, they reprogrammed and headlights worked for three days, then went passenger low beam went out again. Took back to dealer and now they are telling me both headlamp control modules on both sides need replacing. The cost is very expensive and I am doubting this is the problem. This is a safety issue and I am reading blogs and the Platinum version of the Explorer seem to have issues. This could cause an accident and Ford could be liable. This issue needs to be looked at, as this should not be an issue for a car with 50K miles on it.
Nov 26, 2025
Vehicle blinker works at fast rate at all times. In the event that one of the rear turn signals stops working, the vehicle will not adjust the turn signal flash rate frequency to warn the driver that a turn signal is not working correctly. Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment." Ford says 'fast' blinker on all Explorer ST's is by design and normal.
Jan 01, 2024
Headlamps stay lit even in auto lamp mode. Indicator on the dial does not display which mode or setting the lights are in. This has occurred numerous times and seems to have increased frequency
Oct 09, 2023
FUEL SYSTEM, GASOLINE
4 complaints
The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The contact stated that after purchasing the vehicle, while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal. No warning light was illuminated. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 60,000.
Oct 27, 2025
The contact owns a 2021 Ford Explorer. The contact stated that while depressing the accelerator pedal, the vehicle hesitated while accelerating and decelerated unintendedly. The contact stated that the failure mostly occurred during the warmer weather months. The cause of the failure was not determined. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 55,000.
Jul 15, 2025
The contact owns a 2021 Ford Explorer. The contact stated that after parking the vehicle, there was an abnormal fuel odor inside and outside the vehicle. The vehicle was taken to the local dealer who diagnosed that the fuel hoses had ruptured due to the hoses making contact and rubbing together. The contact was informed that the fuel hoses needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure but offered no assistance. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 19V859000 (FUEL SYSTEM, GASOLINE). The contact indicated that the vehicle had experienced the failure listed in the recall. The failure mileage was 44,000.
Dec 03, 2024
The contact owns a 2021 Ford Explorer. The contact stated while driving 10 MPH, there was a strong gasoline odor inside the cabin of the vehicle. Additionally, the contact stated while the vehicle was parked in the garage, there was a strong gasoline odor coming from the vehicle. The contact stated that the gasoline odor was present throughout the entire three-story residence. There was no warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that the fuel line was leaking from a hole. The fuel line was replaced, and the diagnostic fault codes were cleared. The contact stated that upon reviewing photographs of the fuel line, he noticed that an unknown component had been rubbing against the fuel line, which caused the failure; however, the dealer did not inform him of the cause of the failure. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 41,000.
Feb 14, 2023
FORWARD COLLISION AVOIDANCE
4 complaints
As I am traveling on the freeway or expressway, when I have cruise control active and I am in the far right lane the vehicle suddenly changes to the speed of the frontage road dropping my speed from 65 or 70mph down to 40, even tho I am on the expressway. It almost caused me to be rear ended because of the sudden drop in speed.
Jun 10, 2025
While driving around 45 miles per hour the vehicle braked on its own without any vehicle in front and dropped to 5 miles per hour, the dash displayed Brake Assistance. While that happened a car behind me came close to rear-ended my car. At this time the vehicle is at the dealer, it was towed. This is the first time this happened, the vehicle showed no warning before the incident. The fact the vehicle behind came so close to rear-ending my car makes this a safety concern, if this happened at a higher rate of speed the consequences could have been more serious.
Mar 14, 2024
The contact leases a 2021 Ford Explorer. The contact stated while his wife was driving at 25 MPH with Co-pilot 360 assist mode and the evasive steering assist engaged, she lost control of the steering wheel. The contact stated that his wife could not feel the connection between the steering wheel and the front tires of the vehicle. The contact stated that the vehicle made a sharp right turn and crashed into a telephone pole. There were no warning lights illuminated. The air bags deployed. The contact 's wife sustained bruises and lesions on the ankle, knee cap, arms and on her left breast but did not seek medical assistance. A police report was filed. The vehicle was towed to a tow lot. The vehicle was then towed to another tow lot where it was totaled. The dealer was not notified of the failure. The manufacturer was notified of the failure and informed the contact that they could not assist. The failure mileage was approximately 12,000.
Mar 09, 2022
Audio Control Module failed on 2/17/22. No audio for Forward Collision Warning, Rear Cross Traffic Warning, and reverse sensors. Dealer replace ACM, which fixed the issues on 2/22/22. However on 2/27/22, the speakers started making a popping crackling noise and front speakers went out. Then a few minutes later, no audio for about 15 minutes, but the popping noise still continued. After no audio for about 15 minutes the driver side speakers started to work, but the popping noise continued. Vehicle will be going back to the dealership.
Feb 28, 2022
ELECTRICAL SYSTEM,ENGINE
4 complaints
The contact owns a 2021 Ford Explorer. The contact stated that while at a stop sign, the vehicle lost automotive power and failed to restart. No warning lights were illuminated. The vehicle was taken to a local dealer, where it was diagnosed; however, the cause of the failure was undetermined. The vehicle was not repaired. The contact stated that several unknown warning lights were illuminated. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 74,000.
Mar 21, 2025
[XXX] after driving less than 10 min. warning signs flashed on screen. I immediately pulled off the road where the vehicle completely shut down and realized my 2021 Ford Explorer was on fire. Bystanders attempted to put the fire out with fire extinguishers but were unsuccessful. My passenger and I opened our doors, I exited and attempted to open trunk to remove wheelchair but could not (because door is electrical). My passenger flung himself onto the ground until bystanders came with a rolling office chair to remove him away from the burning vehicle. Had the bystanders not been there I do not know how I would have been able to move my passenger (25 year old, 200 lb male) away from the burning vehicle. Fire Marshall could not determine cause of fire because vehicle was completely melted/too damaged. Ford Motor Company reviewed photos I sent to them but claims they could not determine cause of fire. The vehicle was properly maintained with routine oil changes. There were no issues with the vehicle prior to this incident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Aug 22, 2024
I was sitting at a stop light and when the light turned green I pushed on the gas pedal and I had NO POWER! However, all of my auxillary power worked. Everything inside the car still had power, from my dashboard to my Apple CarPlay but my engine would not turn on. The check engine light did come on but not until it had been sitting there for 20-30 minutes. The Auto Start/Stop was activated so I don't know if there was an issue with that and it just never turned back on. The alternator belt was still intacted. Had it towed to repair shop (took about an hour) when it got to repair shop it started and shop couldn't find anything wrong. It has started every time since. I am afraid to drive it because I don't know if or when it will happen again.
Oct 05, 2023
Got it in the car and pushed the push start button. The cars engine turned over only half way and started to restart and turn over multiple times even though the motor was running halfway. This went on for 15 minutes until i opened up the hood and looked down and after a couple minutes the engine seized and turned off and started smoking, shortly after started on fire from the bottom of the engine. The fire went on for 10 minutes until we turned it off.
Mar 31, 2022
UNKNOWN OR OTHER,VISIBILITY/WIPER
3 complaints
Automatic roll up sun shade for the sunroof sags and does not retract anymore, causing visibility issues as it droops down. Car is out of factory bumper to bumper warranty, currently 52k miles, and the aftermarket warranty does not cover the shade. Ford quoted over $2000 for fix, when this is a manufacturer's defect and many cars are affected.
Aug 08, 2025
Moon roof cover is sagging and interfering with visibility with the rear view mirror. There have been many incidents of the sagging occurring online in for forums. There have been no warning notices for this issue
Apr 28, 2025
Two issues. 1. After the software update that was supposed to fix the rear camera blue screen issue, it randomly shows a blue screen instead of the camera image when reversing. The issue doesn't correct until the vehicle is turned completely off and restarted. 2. The rear hatch randomly closes when getting items out or putting items in the cargo area. It cracks you on the head and DOES NOT STOP. If you can't get out from under it in time you fall to the ground. More than once it has made me see stars it struck my head so hard. Also sometimes when walking away from the vehicle the hatch will open on its own with no one near it. The dealer tried once to reproduce the issue but didn't happen while they had it.
Sep 11, 2022
AIR BAGS
3 complaints
The airbag burnt a hole in a cotton shirt and then left 2nd and 3 degree burns on my side.
Jun 22, 2025
The contact owns a 2021 Ford Explorer. The contact stated that he was driving approximately at 55 MPH when a deer jumped out in front of his vehicle. As a result, the contact crashed into the deer and the air bags did deploy, however when it did it was very aggressive. The contact stated that he and his wife were both sustained multiple injuries caused by the airbags. The contact stated the passenger suffered injuries to both her eyes causing blindness and isn't certain if it would be permeant. The contact stated that he sustained injuries to his wrist, neck, and leg. The contact stated the ambulance was called and took them to the hospital where they received treatment. The contact stated the vehicle was towed to a junkyard service, and from there towed to the dealer where it remains currently. The contact was advised that his vehicle may be totaled and that he should await further details. The failure mileage was 3,000.
Dec 20, 2021
On 11/25/2021, I started the vehicle and drove about 2 miles when I noticed that the airbag light was illuminated on the dash. Knowing that this is a safety concern, I pulled into a parking lot and shut off the vehicle. I let the vehicle sit for about 30 seconds and restarted the car. When restarted, the light did not come back on. Took the vehicle in to have a recall performed and told the service advisor that the light had come on. They confirmed that there was a "stored code" but "not something that made sense". The dealership has had the vehicle for 9 days with no resolution. They say that a wiring pigtail harness needs replaced but also that there is a fault in the driver's seat airbag. The replacement airbag is not available due to a backorder (told 3-4 weeks). I feel that this is a large safety concern as I was told I could pick up the vehicle until the parts become available knowing that there is a fault in the airbag. The failure occurred with 3410 miles on the odometer.
Dec 13, 2021
SUSPENSION,POWER TRAIN
3 complaints
the rear axle bolt fractured while driving causing damage to the differential, axles, and mounting bushing. the problem has been confirmed by Baytown Ford Dealership service dept. located at 4110 I-10, Baytown, TX 77521. it has been inspected by the Service Dept at Baytown Ford. located at 4110 I-10, Baytown, TX 77521 no prior symptoms or warnings.
Mar 25, 2025
Vehicle developed a clicking noise when accelerating/decelerating. Noise also present when switching between drive/reverse. Ford dealer found that driveline was flexing. Closer inspection revealed that the bushing for the single bolt rear subframe mounting to rear differential was broken. Had this not been caught, the bolt would have broken releasing the rear driveline from the structure of the vehicle. The 2020 Ford Explorer ST had two bolts that connected the rear diff to the rear subframe. In 2021-2022 Ford changed this to a one bolt design. This triggered the current recall for the 2021-2022 in which the 'fix' was to apply the emergency brake if the bolt broke. On the 2023 Ford Explorer ST model, Ford has returned to the two bolt design used in 2020. Photos uploaded.
Feb 16, 2023
Ford has started a recall for vehicles with a single bolt in the rear differential mount. This is in reference to the roll away issue as their calling it. Some people have recieved notice for this and others have not. My production date is listed as 8/21. Which I believe is in part of the recall. Even if not this vehicle has only one bolt in the unit and not 2. Which is part of the recall issue.
Sep 19, 2022
FUEL/PROPULSION SYSTEM
3 complaints
I have had this problem ever since we Purchased this automobile on [XXX], When the car gets to a Quarter tank of gas or a little less the dash monitoring system says there's 87 miles left till empty and you park this car on a hill or incline with the front end facing down the car will not start and everything shuts down. The only way to restart it is to put more gas from a can in it or go through a long process to takes two people to do to get the car on a level area then it will restart. I call the Dealer abut it and they said there is no problem. The car had to be towed twice in the first few months we had it for this and as soon as they got it off the truck it would start and they do nothing about it. I call Fords Hot line and they said they know about the Problem but can't do anything about it , I was told that its a fuel pickup Problem. Today [XXX] my wife when to the store this morning and the fuel gage said it had a quarter tank of gas in it and when she came out of the store the car would not start for her. I had to go and get a 5 gal. can of gas and drive to where she was and put the gas in the car and after that the car started, she drove to the nearest gas station to fill it up. All I have been told to do by Ford and the Dealer is to keep the gas tank full and fill it when it gets to half a tank. There is definitely a problem with this car and it needs to be Addressed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Nov 27, 2024
Was trying to get gas and the door to the gas lid would not open. Waited for over an hour for someone to help me. Get the door open. Only had 10 miles to empty and the closest town is 20 miles.
Jul 08, 2024
Strong egg odor from exhaust when temperature is below 0 degrees C or 32F. This is especially the case then the car is started and left to warm up for 5-10 min. The smell goes away after 15-20min.
Jan 04, 2024
SERVICE BRAKES,FORWARD COLLISION AVOIDANCE
3 complaints
All of the ADAS along with the brakes of my vehicle fail. The dealership failed to inform me of the recalls prior to purchase. The dealership in town shows all of the parts in stock in their parts department but claim not to have any parts available. When I called, I was given the runaround then sent to a voicemail. When I showed up to the dealership they stated they can only order certain amount of parts and I wasn’t on the list yet was told over the phone I was placed on the list on May 22 2024.
Jul 22, 2024
I haven’t been problem with the parking !When I set the packing bottoms it’s turns automatically into rear I already have an issues with that !! almost kill my son an nephew I’m scared this happened again in the parking lot at store almost crash other vehicle! I need my car fixed as soon is possible I hope I hear from your side! Thank you!!!
Dec 02, 2023
I already having problem with the parking !When I set the packing bottoms it's turns automatically into rear I already have an issues with that!! almost kill my son an nephew I'm scared this happened again in the parking lot at store almost crash other vehicle! I need my car fixed as soon is possible I hope I hear from your side! Thank you!!!
Dec 02, 2023
SUSPENSION
3 complaints
My driver side cv joint went out Dec 2023, noticed grease, throwing while a tire rotation was being done. April 2024 was completing a oil change and we decided to check the passenger side and now that CV joint is going out as well. This vehicle has less than 30,000 miles on it.
Apr 05, 2024
I bought my 2021 Ford Explorer brand new and at 44,675 miles my shock absorbers went bad. There was no damage to my vehicle that could have caused it, my car was never in an accident. The dealership that repaired them said there was no indication of what caused it and it is highly unusual. Driving without shocks on my vehicle caused the loss of ability to control the rate of weight transfer when going around corners; this also resulted in increased steering input to navigate turns and uneven tire wear.
Oct 21, 2023
The contact owns a 2021 Ford Explorer. The contact stated that while driving at various speeds, the rear end of the vehicle became very unstable, and the vehicle fishtailed. The vehicle was taken to the local dealer who performed a rear wheel alignment, but the failure persisted. The manufacturer was notified of the failure and informed the contact that the VIN was not included in the NHTSA Campaign Number: 21V870000 (Suspension). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 12,000.
Apr 07, 2023
VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE
3 complaints
With the Ford Intelli-Cruise enabled in settings, the vehicle automatically adjust the speed while using the cruise control. The vehicle will randomly, quickly, accellerate to a extreme new speed limit it thinks it has detected. For instance, several times while travelling on I-81, with a 70mph speed limit, the vehicle will think the new speed limit is suddenly 85mph and quickly accelerate to that speed. I have attached a photo of the dash displaying that setting the car set by itself. On the flip side, once on I-81, it thought the speed limit was 35mph and quickly slammed on the brakes to slow to 35mph from 70mph. Both are quickly overridden by the driver tapping the brake and cancelling the cruise control. However, both could lead to hazards to other drivers potentially resulting in a wreck, especially the sudden slow to 35mph on the interestate. The dealership says "Yea, it happens and people complain". I have no idea why the speed changes, there are no road signs or other indications to even cause the system to re-evaluate its settings. Ford says Intelli-Cruise uses road signage and other ways to also determine speed (whatever that means). This is a safety issue that needs to be remedied by Ford. However, without NHTSA enforcement, they don't seem interested in resolution. (This website isn't allowing me to upload the .jpg file, upload button disappears when I click it)
Jan 01, 2024
While using Intelligent Adaptive Cruise, the vehicle suddenly thought the speed limit was 85mph and quickly started accelerating. Confused, I hit the brakes to stop the acceleration. I have uploaded a photo of the dash that I took showing that the system read the speed limit sign as 85. I saw no speed limit sign in the area, so, I have no idea what prompted the system to change speed. I was talking on the phone via Android Auto and using Waze, via Android Auto, USB direct connect. The only other problem I've ever had with this system is on interstates that have specific Truck speed limits in West Virginia. There, sometimes trucks have slower speeds and this system picks up those truck speeds and decelerates/brakes to comply. While it can be overridden in the moment, the next time it sees such sign, it slows again. This sudden deceleration poses a hazard to other drivers who do not expect a 'non-truck' vehicle to suddenly slow.
Feb 16, 2023
Adaptive Cruise control reads the overhead electronic posted 65MPH speed limit signs as 85MPH. This only occurs when traveling on I-670 eastbound between Leonard Ave and I-270 on the east side of Columbus Ohio...This section of highway was recently upgraded with "Smart Lane" overhead electronic signs. The dash on this vehicle shows the posted speed limit at all times, but if the cruise control is on the vehicle with automatically go to what it reads and in this case goes to 85MPH! I have driven this vehicle over 5000 miles in 4 different states and this situation only occurs at this particular locatiion. I have contacted State of Ohio, Department of Trtansportation and discussing this issue with Drive Ohio representative Luke Stedke ( [email protected])
Aug 04, 2021
STRUCTURE,UNKNOWN OR OTHER
2 complaints
Roof window cover/headliner has come loose and is impeding full vision to the rear of the car while the headliner is retracted.
Oct 31, 2025
When driving at low speed, every uneven thing in the road surface creates a low resonating frequency sound (deep base) through out the cabin.
Jan 26, 2024
SERVICE BRAKES, HYDRAULIC
2 complaints
The contact owns a 2021 Ford Explorer. The contact stated that while her husband was driving at an undisclosed speed, the brake pedal was sticking on three occasions. The contact stated that while driving at an undisclosed speed in a parking lot, the contact had to raise the brake pedal with her foot after the brake pedal was depressed. The contact stated that it felt like the parking brake was engaged. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the power brake booster was inoperable. The part: L1MZ2005K - Ford Power brake booster was on back order for a month. The vehicle was taken to an independent mechanic who repaired the brakes, and informed the contact that the required parts were on back order for three months. The contact called the manufacturer, who confirmed the status of the parts, and that there was no release date for the parts. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 85,000.
Aug 07, 2025
Vibration: First use of the day, at about 35 MPH vehicle exhibits vibration throughout, especially around 40-41mph. Felt in steering wheel, seat, and with a loud rumble often heard. Has been since car was new. Has a vibration in rear view mirror at highway speeds. Goes away after driving for 15 miles or so, and at least a half hour. Returns after vehicle cools off. Cruise control: Adaptive cruise sometimes causes extreme braking at highway speeds for no reason. This happened while driving past a vehicle on Alligator alley causing all my passengers to comment, even though I had not touched the brake. Happened again 10/28 on 75 coming down from Sarasota. Braking: ABS engages on dry roads, especially when turning, for example into a driveway, but it cold be just a normal stop for a traffic light. The brakes also “grab” when coming to final stop, causing the car to stop suddenly
Oct 30, 2021
VEHICLE SPEED CONTROL
2 complaints
2021 Ford Exploer the RPM SHOOTS UP AND DOES NOT GO DOWN. I HAVE TO PULL OVER AND SHUT VEHICLE OFF TO RESET.. This has been replaced in 2023 and I am having problems with same issue. VEHICLE WILL NOT PICK UP SPEED UPON Accelerating and when it finally picks up the transmission with jerk really hard. This happens 2x a week. At times I have to pull over because there is no speed when pressing on the gas and need to shut off my car to reset it. When pressing on the gas pedal it Will sped up and take off with light Touch from gas pedal .
Apr 06, 2025
I have filled claims with Ford Motor Company as well as the BBB regarding my vehicle and not shifting and lunging into gear. Ford has replaced my transmission 3 times and denied my claim for a buy back under the Lemon Law and Magnuson Moss Warranty claim. Now I am reading Ford is recalling many 2021 Ford Explorers for the same issue that I had reported struggled and continue to struggle with for over a year now. Is there anything NHTSA can do to require Ford to purchase my vehicle back for at least what I paid for? I can provide claim numbers, if needed.
Jun 26, 2023
POWER TRAIN,FORWARD COLLISION AVOIDANCE
2 complaints
The contact owns a 2021 Ford Explorer. The contact stated that while reversing, the vehicle suddenly shifted into park, after which the vehicle went into LIMP mode. After restarting the vehicle, the vehicle was unable to shift out of park and displayed the "Automatic Emergency Braking Unavailable" message. The traction control, start-to-stop, and hill start assist warning lights were illuminated. The vehicle was taken to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 30,500.
Dec 15, 2023
Vehicle loses power while on freeway when 4WD, Pre-Collision Assist, Hill Start Assist, and other warning messages display. Vehicle lost power approximately 5 times while registering message, but messages have displayed approximately 40-50 times in the past week before being services. Vehicle dealership repair facility inspected and diagnosed a bad 4WD module.
Sep 26, 2023
POWER TRAIN,BACK OVER PREVENTION
2 complaints
The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 21V735000 (Back Over Prevention), 22V255000 (Power Train), and 23V675000 (Power Train) however, the parts to do the recall repairs were not yet available. The local dealer was contacted and determined that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.
Nov 15, 2023
The contact owns a 2021 Ford Explorer. The contact stated that upon starting or while driving the vehicle, the front camera screen image was black or gray before going blank. Additionally, the navigation system was inoperable. There were no warning lights illuminated. While driving at undisclosed speeds, the transmission was slipping. The vehicle was taken to the local dealer, where it was diagnosed that coolant had intruded into the transmission. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 50,000.
Sep 22, 2023
ELECTRICAL SYSTEM,UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM
2 complaints
The vehicle was self accelerating and applying forward propulsion. It was behaving as if the cruise control was on, cruise control was verified off. When braking was applied an alert was posted on the dash stating Braking applied, power reduced and the engine would rev higher. Upon stopping the vehicle and letting off on the brake the vehicle would accelerate as if the gas pedal was depressed. Upon parking the vehicle the engine would rev up to 6k rpm and if I let go of the brake the vehicle would accelerate. Turing off the vehicle and turning the vehicle on did not reset the issue. I verified no inadvertent pressure was being applied to the gas pedal and have video demonstrating the failure. The videos I have are too large to upload via your limitations on this page.
Oct 02, 2023
In the last 2 months I have had a total of 3 back up cameras and the equipment is still turning blue on random. I have had the wiring replaced to “fix” the Bluetooth echo, and it is still doing it. The gas take also shakes enough to move the car when you come to a stop depending on amount of gas in the tank.
Jun 10, 2022
POWER TRAIN,VEHICLE SPEED CONTROL
2 complaints
While driving on a freeway on Sep 15th 2023, wrench light showed up and immediately vehicle speed dropped from 65 to 30mph. This is second time this issue has happened and luckily my family survived accidents. First incident occured on Aug 13th 2023, after which i towed my vehicle to dealership. They repaired and said its safe to drive now. But issue is recurring. Please help me on this as I am reporting this issue second time on NHTSA. I reported first incident also which happened on Aug 13 ,2023
Sep 16, 2023
The contact leased a 2021 Ford Explorer. The contact stated while driving approximately 25 MPH, the vehicle accelerated independently. The contact stated that five minutes later the vehicle went into safety mode and the vehicle failed to move. The low battery message was displayed. The vehicle was towed to the residence. The contact called the local dealer but, the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 7,600.
Dec 14, 2021
LANE DEPARTURE,BACK OVER PREVENTION
2 complaints
The back up camera fails basically 1 out of 5 times it's engaged between skipping or just straight blue/black screen. The screen is out and causes blind spots while backing up.
May 19, 2023
All of the sensors are out. Nothing is working. They were working fine then one day I noticed the lane keeping sensors were not working. Today I noticed the side sensors are not working which they were this morning. The middle row seat gets stuck if moved forward, it will not stay back. The button is always stuck so while on the road the seat randomly pops out of place. The wipers do not work properly, only on high speed. I have already called McCombs Ford West in San Antonio, Tx as I purchased the vehicle there in October of 2021 but they are not worried about it. They said I can go drop it off but they will check it when they get a chance and will not provide a loan car which I cannot do that as I have kids. All the safety features that it should have are not working. They told me it would be weeks before they even look at the vehicle.
Jun 22, 2022
ELECTRICAL SYSTEM,SEATS
2 complaints
I am having major issues with the 3rd row seating on my Ford explorer getting stuck and not able to be moved. This is happening causing children to not have places to sit and seatbelts to secure themselves in for a safe commute. Each time the seats are stuck, they are not even able to be moved manually. The entire seat including the head rest becomes immobile and leaves the seat in either a half open/closed position or an open position with no headrest capability. While traveling out of town on January 23 with 6 people in my vehicle my 3rd row seats became stuck in positions where I was unable to safely transport 2 of the occupants of the car. I also had to travel home in an extremely unsafe situation where luggage had to remain in laps for a 4 hour car ride and could have been catastrophic had there been an accident. I reached out to the service department of Palmetto Ford on January 24th about this issue and they told me it would be 3 to 4 weeks until they could get my vehicle in to “look at it.” I reached out to my sales person who was able to coordinate with the service manager to get my vehicle looked at the next day. They did not have a loner for me to drive so they rented one from Enterprise and had me come back the next day to pick it up and began to repair my car. It took them about 2 days and they said they had to completely replace the computer brain of the 3rd row seating. When I left it was in working order. Two months later while once again out of town with 4 other people’s children to care for my 3rd row seating gets stuck again in an unusable position. This time I had no other alternative but to put these kids in seats together seatbelted in and pray that I did not get hit. When I got home on March 29th I called Palmetto Ford sales to let them know that my seats are once again broken and spoke to the sales manager Jake. I told him that I felt unsafe in the vehicle now and that I would like them to take it back. I told him I had more travel
May 13, 2022
Third row seat won't go up or down (it is an electrical seat for folding flat or to lift back up for seating). On Aug 12, 2021 took it to Ford dealership near me for any appointment to have fixed. In morning of Friday 13th dealership said still hadn't figured out the problem. By afternoon of 13th August dealership said it is either module or buttons issue and said they needed keep it over weekend. Dealership said they d call me by noon on Monday 16th August to let me know. Well, since I hadn't heard from then I called them again (as I have been doing since they dont seem to communicate with customers). Callie of Service dept said its the buttons/switches. That must order them; closest place had them is Tennessee she said. We are concerned for we had these exact issues with 2015 Explorer; started with 3rd row seat then all other electrical issues started happening. That explorer suv was in shop for several months.
Aug 16, 2021
AIR BAGS,STRUCTURE
1 complaint
Dashboard not attached to frame. Clips intended to attach dashboard to frame are defective (cracked in half). Air bags may be affected (either won't deploy or will deploy on their own). Service Dept. at Ford dealership says this is the first case they've seen and repairing it would cost $$$. This vehicle has been regularly maintained and has 0 history of accidents. It is unknown if this defect has existed from the date the car was purchase(or earlier).
Nov 19, 2025
UNKNOWN OR OTHER,ENGINE
1 complaint
My vehicle is experiencing exhaust fume issue where the exhaust fumes are entering into the cabin for Explorer and Aviator models (Any model with the 3.0L Ecoobost). Upon inspection by 3rd party mechanic, it can be determined that the problematic catalytic converters that are not the one piece cast was installed on my vehicle from the factory. Speaking to other ST and Interceptor owners, the problem seems widespread to every 2021 model that Ford installed the multipiece welded catalytic converters. Apparently the cast part fairs better and is not subject to cracks. The recall originally covered the left side catalytic converter but the flawed design also affects the right side catalytic converter where many owners are experiencing this issue. This has affected all 3.0L Ecoboost engine vehicles. [XXX] I believe the recall should have extended to cover all 2020 and 2021 model year vehicles. There are forum posts where owners outside the recall have experienced the issue in addition to owners having to repeatedly replace the catalytic converters post warrant as Ford continued to reinstall bad catalytic converters as part of the repair process. I have driven this vehicle for several thousand miles with the issue and did not realize exhaust was leaking until notices of headaches and health issues as CO is odorless, causing CO2 levels to reach 3000+ inside the cabin at stop lights and blows in through the vents if A/C is on. I believe NHTSA should investigate this issue further and require Ford to replace both catalytic converters as this issue poses a serious health hazard, especially given the location of the exhaust leak and the commonplace occurrence. I am happy to forward to forums and provide evidence of this occurring. Ford considers lifetime of the vehicle to be ~150K miles and these exhausts do not last close to that, resulting in a massive expense and danger to US consumers. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Nov 17, 2025
EXTERIOR LIGHTING,UNKNOWN OR OTHER
1 complaint
LED LIGHT ISSUE. PASSENGER SIDE LOW BEAM. LIFETIME OF LED SHOULD BE 45,000 HOURS OR 12-15 YEARS. IT IS NOT WORKING. FORD NEEDS TO GENERATE A REPAIR ALSO CURRENT WARRANTEE WORK NEEDS TO BE COMPLETED INCLUDING THE REAR CAMERA.
Oct 12, 2025
SEATS,BACK OVER PREVENTION
1 complaint
The contact owns a 2021 Ford Explorer. The contact stated that while the vehicle was parked, the rearview camera became inoperable. The contact stated that the rearview camera image was blank. The contact received notification of NHTSA Campaign Numbers: 25V159000 (Back Over Prevention) and 25V393000 (Seats). The vehicle was taken to the dealer but was not diagnosed or repaired. The dealer confirmed that parts were not yet available to repair the vehicle. The manufacturer was made aware of the failure. The approximate failure mileage was 90,000.
Aug 14, 2025
POWER TRAIN,ELECTRICAL SYSTEM,ENGINE
1 complaint
The transmission failed. The electrical component also failed
Jul 31, 2025
ELECTRICAL SYSTEM,SEAT BELTS,ENGINE
1 complaint
Recall Action Soon Issue Since 06-20-2025 Unrequested second-row seat movement For More Information Telematics Generated Issue
Jul 20, 2025
ENGINE,FUEL/PROPULSION SYSTEM,FORWARD COLLISION AVOIDANCE
1 complaint
Recall Action Soon Issue Since 06-20-2025 Unrequested second-row seat movement Unrequested second-row seat movement Recall incomplete Recall service not available right now. We have a remedy but parts are not available right now. We will inform you when the service is available. Or, you can contact your dealer. Contact Dealer Issue Date 2025-06-13 Campaign 25S67/25V393 Description On your vehicle, it is possible that the easy entry seat fold switch on the second-row outboard seats may bind or stick if its surrounding trim bezel was installed incorrectly. If the button is stuck in the down position, the seat may unlatch, fold and or slide unexpectedly, potentially while driving. Safety Risk A seat that unexpectedly folds or slides while driving could increase the risk of injury, particularly in a crash. Remedy Ford Motor Company is working to provide parts for this repair. When the remedy becomes available, Ford Motor Company will notify you via mail to schedule a service appointment with your dealer for repairs to be completed free of charge.
Jul 19, 2025
FUEL SYSTEM, GASOLINE,ENGINE
1 complaint
The contact owns a 2021 Ford Explorer. The contact stated that while driving approximately 20-30 MPH, the vehicle stalled, with the check engine warning light illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the VIN was not included. The vehicle was towed to an independent mechanic. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 55,000.
Jul 17, 2025
POWER TRAIN,VEHICLE SPEED CONTROL,FUEL/PROPULSION SYSTEM
1 complaint
my explorer has a 10 speed transmission, and its REALLY heavy on shifting like it is missing shifts or slipping, it will shoot up in rpms to the 7-8k mark and jerk forward, this will happen every few minutes when varying speed, driving through residential areas or normal trafficways not including the highway, however on the highway it has a tendency to feel as if it loses power and regains it, dropping rpms and shooting back up to 4-5k rpm, and dropping back down to around 2k. today i had the incident where the car jerked hard after a shift, gave me prompts on the dash about seeing the manual, and that drive modes are not available. this has happened in the past month before multiple times, however this time i lost all power to acceleration going down the road, ended up just coasting to a stop on a road that speed limit is 55 mph. this made me panic, because i could have possibly been rear ended, or in any other case could have been hit if my car would not have properly been able to accelerate. the car has had similar problems reported from previous owners and they have been taken into a dealership for repairs of which did not fix the problem or the problem is reoccurring. there are no warning lamps prior to the jerkiness of shifting and loss of acceleration because of it. it will jerk a handful of times and eventually give me the "see manual" prompt after the initial problem was noticed, i decided to look online for answers as to what was wrong and it seems like this is a reoccurring problem with vehicles similar to mine. Hopefully it hasnt caused and injuries, but it definitely has the possibility to from what i have experienced.
Jul 15, 2025
UNKNOWN OR OTHER,SERVICE BRAKES,ENGINE
1 complaint
I was stoped at a red light with cars in front of me and behind me when with my foot on the break the car accelerated forward like my foot was on the gas pedal but my foot was not on pedal, the car surged forward and came close to hitting the car in front of me I pressed the break and got stopped didn’t happen again but sometimes I can feel the car wanting to keep surging forward when breaking. If there is a problem this could cause me to hit someone in the rear or even worse could hit a pedestrian in the crosswalk please check this out
Jul 14, 2025
LANE DEPARTURE
1 complaint
2021 Ford Explorer •Problem: Blind Spot Detection / Sensor Malfunction •Description to copLeft-side blind spot sensor fails intermittently. It shows no warning when vehicles are in the blind spot, creating a risk during lane changes. I found Ford TSB 23-2048 confirms the issue. Dealer quoted $1,200 but this is a known factory problem and safety issue.
Jul 10, 2025
Carry Handle, Shell, Base,Other/I am not sure
1 complaint
We bought this in 2022 from clek, and a few months before we were transferring our daughter from the infant seat to a convertible seat, our infant seat became stuck on the base. Absolutely impossible to get off and my husband and I both tried many times. I reached out to Clek because I was very concerned that in an emergency situation it would take much longer to unstrap and get baby out instead of just grabbing the seat and going. I mean in a car fire, if we went in any body of water- anything it’s extremely concerning to me that this could happen. I have bought cheaper car seats than this for our other children and never once had this issue. They ended up emailing me with a video showing me to break the base, pull a strap and remove the seat from the base - that’s great besides it still won’t detach and you could never do this in an emergency. They also said this happens often which clearly it does if they have a video showing how to remove it. The car seat has been inspected by the hospital and police prior to this and we have had other friends/ family who are in those professional fields who were very concerned. We actually were told by Albee baby to report clek because they said they should refund us. They aren’t even offering us a new seat and we are due in less than 2 months with baby number 3. We have no seat and to be truthful I don’t want one like this where it may get stuck again. They also told me in an email, police and ems could help save my child- sometimes you can’t wait for that- that’s a horrible excuse to me. I should be able to save my children myself and I will never rely on anyone else.
Jun 01, 2025
FIRERELATED
1 complaint
The contact owned a 2021 Ford Explorer. The contact stated that the vehicle was parked in the driveway for over three hours before the vehicle caught on fire. The origin of the fire was unknown, however, the contact believes the fire originated from faulty electrical wiring. The vehicle was unoccupied during the fire. The location of the fire was the rear end of the vehicle. The fire department arrived to extinguish the fire. A fire department report was filed. A police report was not filed. The vehicle was destroyed. The local dealer was contacted, and the vehicle was not diagnosed as it was determined to be a complete loss. The manufacturer was notified of the failure. The approximate failure mileage was 75,000.
May 23, 2025
ELECTRICAL SYSTEM,UNKNOWN OR OTHER
1 complaint
My vehicle is having the blue screen & message to contact my dealer when in reverse. I understand there is a recall for this. I contacted ford to see why I haven't received a notice & am being told that it only affects certain vehicles yet I'm having the exact issue. It is a safety hazard due to low visibility behind the vehicle when in reverse.
Apr 25, 2025
ELECTRICAL SYSTEM,VISIBILITY/WIPER
1 complaint
Sun shade sagging. Causing loss of visibility.
Apr 02, 2025
STEERING,SUSPENSION,UNKNOWN OR OTHER
1 complaint
Queja por reparación defectuosa de recall en mi Ford Explorer Estimados Señores: Por medio de la presente, me dirijo a ustedes para expresar mi profunda insatisfacción con el servicio recibido en su concesionario relacionado con un problema de recall en mi Ford Explorer [indicar modelo y año del vehículo], cuya reparación, realizada bajo su supervisión, no ha sido adecuada. En los primeros meses de 2024, llevé mi vehículo a sus instalaciones debido a un recall emitido por Ford, relacionado con un sonido de media frecuencia resonante (de tono profundo) que se manifiesta al conducir a baja velocidad sobre superficies irregulares. Según se me informó, este problema fue causado por un defecto en una pieza, la cual supuestamente fue reemplazada en su momento. Sin embargo, después de meses de lidiar con el inconveniente inicial y tras un extenso tiempo de espera, el problema parecía haberse solucionado temporalmente. Desafortunadamente, en noviembre de 2024, el problema ha reaparecido exactamente con las mismas características, lo que me lleva a sospechar que no se realizó un reemplazo adecuado de la pieza defectuosa, sino únicamente un ajuste superficial. Al comunicarme nuevamente con su concesionario, se me ha informado que no pueden hacer nada más porque el supuesto reemplazo ya se realizó. Este tipo de respuesta es inaceptable, considerando que: 1.El problema persiste y claramente no fue solucionado de manera definitiva. 2.El recall original fue emitido para garantizar la seguridad y funcionalidad del vehículo, lo cual no se está cumpliendo. 3.Como cliente, esperaba un servicio honesto y de calidad, especialmente tratándose de un problema cubierto por un recall oficial. Solicito formalmente que este caso sea reabierto y revisado nuevamente, ya que mi confianza en la calidad de los servicios proporcionados se ha visto seriamente afectada. Espero que Ford y su concesionario asuman la responsabilidad correspondiente y brinden una solución definitiva al problema
Jan 13, 2025
SUSPENSION,UNKNOWN OR OTHER
1 complaint
Recently brought my 2021 Ford Explorer with 100,000 miles in for what I thought was a wheel bearing issue. The mechanic reports the entire rear end is gone and needs to be replaced. I’ve owned at least 4 Explorers all driven well over 170,000 without ever having this issue. This car also spent the first 3/4 months I owned it at the Ford garage getting the electrical replaced and “brains”. The crash alert system malfunctioned as did the locking system.
Dec 28, 2024
VISIBILITY,LATCHES/LOCKS/LINKAGES
1 complaint
The contact's son owns a 2021 Ford Explorer. The contact stated that while driving at 5 MPH down a hill and making a left turn, the hood was unintentionally released, swung open, and hit the front windshield causing it to shatter. There was an abnormal snapping or popping sound detected. The driver pulled over immediately since their view was obstructed. No warning lights were illuminated before the failure however after the hood shattered the windshield the "hood open sensor" light was displayed. The driver's pregnant fiancé was occupying the front passenger's side seat and sustained injuries and pain to her left side. There was glass in her lap, and medical attention was provided. The vehicle was towed to the local dealer but was not diagnosed or repaired. The manufacturer was notified of the failure and referred to the NHTSA Hotline. The approximate failure mileage was 55,401.
Nov 04, 2024
STEERING
1 complaint
Steering is sticking
Oct 27, 2024
SEAT BELTS
1 complaint
The contact owned a 2021 Ford Explorer. The contact was stopped at an intersection traffic signal when she was crashed from behind by another vehicle. The contact's seat belt pretensioner failed to lock and was not able to restrain her. The contact's face hit the steering wheel. The contact had suffered a broken nose, and bruises on her arms. The contact was transported by ambulance to a hospital. The vehicle had extensive crush damage to the rear bumper, lift gate. The vehicle was towed to an impound lot and later declared a total loss by her insurance provider. The police were on scene and issued a report. The manufacturer was informed of the failure. The failure mileage was 36,606.
Aug 06, 2024
ELECTRICAL SYSTEM,WHEELS,UNKNOWN OR OTHER
1 complaint
While driving down the interstate, the tires (rear passenger?) suddenly locked/stuck. This caused vehicle to lose control, 360, and slam into the guardrails. Prior to this incident, when the car was turned on, it stalled a bit like it was about to turn off. This lasted for a few seconds, but returned to normal. So may be a component of electrical and/or directly related to the rear tire. There were no warning messages. Driver was thankful injuries did not occur. Could have flipped, or slammed into other cars, trees, etc. This is a serious issue. While the vehicle was being loaded onto the wrecker, in neutral, the rear passenger tire was visibly stuck. This was observed by owner, husband, police officer and tow company. When offloading from the tow truck, the tire made a loud pop and movement returned to normal. Vehicle is currently at the shop (ford dealership). Will have more information next week from their diagnostic studies. It is available for inspection upon request.
Jun 29, 2024
SUSPENSION,POWER TRAIN,VEHICLE SPEED CONTROL
1 complaint
Ford Explorer 2021 recall stems from a defective rear axle horizontal mounting bolt. Ford Motor Company has promised to cover the cost of replacing the subframe bushing and the rear axle bolt and repairing any resultant damage. The dealer, Payne Ford Weslaco, the Tech broke a tool to fix and Ford has failed to replace said tool.
Jun 25, 2024
FUEL/PROPULSION SYSTEM,FORWARD COLLISION AVOIDANCE
1 complaint
On April 28, 2023, while driving our Forf Explore, we smelled gasoline from our vehicle. We immediately stopped at the next exit, and my husband looked under the vehicle and saw gas dripping from under the engine. We immediately went to the nearest Ford dealership where the vehicle had stayed for a week. We were advised that the leak was one of the metal fuel lines that rubbed onto the frame and caused the leak, also the engine light code was due to the small hole in the fuel line. Which we had taken to a Ford dealership previously due to the engine light on, but they cannot detect the problem. We have contacted Ford Headquarters via phone and mail for further assistance. And up to today, which is April 15, 2024 we have never received a response from Ford Headquarters. This was a very scary situation, which could’ve caused a vehicle fire.
Apr 14, 2024
SERVICE BRAKES,ENGINE,FUEL/PROPULSION SYSTEM
1 complaint
The recall to replace the rear axle bolt was completed and new boil installed. They left the automatic emergency brake program engager which results in the vehicle lurching forward or backward when shifted into gear and results in collisions with other vehicles as the collision detection system is not working.
Apr 10, 2024
VEHICLE SPEED CONTROL,FUEL/PROPULSION SYSTEM
1 complaint
The vehicle looses power occasionally. When the accelerator is pressed it can take a second or 2 to start moving again. It happens when turning, changing lanes or going straight. I could be pulling into traffic and it will stop moving, even if the gas pedal is pressed down all the way. It will happen in every drive mode and when the traction control is off. The only time it hasn't happened yet is when I turn off the AdvaneTrac stability control. I have to hold down the traction control button for 5 seconds every time I start the vehicle. The dealer said they couldn't find the problem. The associate said it's a common issue with the Explorer's. It is very dangerous.
Mar 23, 2024
SUSPENSION,POWER TRAIN,SERVICE BRAKES
1 complaint
I hope this letter finds you well. I am writing to you regarding a persistent issue I have been experiencing with my 2021 Ford Explorer For some time now, I have noticed a loud sound when braking and when navigating obstacles such as speed bumps or when entering and exiting the ramp of my parking lot. Concerned about this situation, I took my vehicle to the service department at your dealership, where I was informed that there was a recall to replace a part related to this issue. I appreciate that you have identified and committed to addressing this problem through the recall. However, I am concerned that despite more than one or two months having passed since my initial visit, I have still not received any notification regarding the availability of the necessary part for the repair. This delay has been particularly frustrating as the problem persists and even seems to have worsened over time. The loud sound when braking and navigating obstacles is becoming increasingly pronounced, significantly affecting the driving experience and my safety on the road. I understand that manufacturing and distribution processes can be complicated, but I need an urgent solution to this problem. As a loyal customer of your dealership, I trust that you will take the necessary steps to resolve this situation quickly and effectively. Since my vehicle is my primary means of transportation, I strongly request that you expedite the repair process and keep me informed of any developments related to the recall and the availability of the necessary part. I look forward to receiving a prompt response and a satisfactory solution to this problem. I appreciate your attention and prompt action in addressing this matter.
Mar 05, 2024
STRUCTURE,VISIBILITY
1 complaint
Roof trim blew off. Moon roof- yes Luggage rack- no Driver side
Mar 01, 2024
POWER TRAIN,ENGINE,ENGINE AND ENGINE COOLING
1 complaint
P25B4- TURBOCHARGER/SUPERCHARGER WASTE GATE (A) STUCK CLOSED P0299- TURBOCHARGER/SUPERCHARGER UNDERBOOST POWERTRAIN AND 4-WHEEL DRIVE IN-OPERABLE, TURNED ON VEHICLE TO DRIVE AND IMMEDIATELY THREW THE TWO CODES ABOVE. FORD SAYS THIS IS NOT A COVERED ISSUE.
Jan 15, 2024
UNKNOWN OR OTHER,VISIBILITY
1 complaint
The rear windshield shattered as I was driving. I did not hit anything, nor did anything hit the rear window. The temperature is -3. I had the defroster on and think the extreme cold mixed with the defroster caused the window to shatter. Is the glass faulty? Or the defroster?
Jan 15, 2024
EQUIPMENT,BACK OVER PREVENTION
1 complaint
The contact owns a 2021 Ford Explorer. The contact stated that the screen display was blue and black and became inoperable. While reversing, the screen was blue. The contact was unable to use the GPS feature. There were no warning lights illuminated. The contact called the local dealer, and the contact was informed that the vehicle could be repaired under warranty. The system showed that the screen had connected and disconnected. The vehicle was not repaired. The contact stated that the failure was related to NHTSA Campaign Number: 23V342000 (Back Over Prevention). The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 42,000.
Dec 14, 2023
WHEELS,TIRES
1 complaint
Two TPMS sensors have failed on this vehicle. Although these sensors are required under the TREAD act, Ford has advised through their dealer that this is not a safety issue and the TPMS sensor batteries failing less than 3 years from date of vehicle manufacture falls in the category of normal wear and tear. Note that the vehicle has 27,243 miles on it, and these are the original TPMS sensors/wheels/tires that the vehicle came equipped with from Ford.
Nov 17, 2023
SERVICE BRAKES,ENGINE
1 complaint
The contact owned a 2021 Ford Explorer. The contact stated while driving approximately 25 MPH he depressed the brake pedal to slow for a traffic signal and the vehicle experienced brake failure. The contact stated no warning light was illuminated. The contact drove over the median to avoid crashing into vehicles directly in front of his vehicle. The contact stated that he was pumping the brake pedal however, the vehicle seemed to accelerate independently. The contact stated that he attempted to shift the vehicle into neutral(N) however, the shifter dial would not move. The contact stated he had attempted to turn the vehicle off but could not turn off the vehicle. The contact stated he was finally able to stop the vehicle prior to crashing into traffic directional poles. The contact stated that the Police arrived on the scene and wrote a report. The contact had the vehicle towed to a dealer who diagnosed the vehicle and determined that the driver's side front shock absorber was damaged and needed to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 22,000.
Nov 09, 2023
BACK OVER PREVENTION,FORWARD COLLISION AVOIDANCE
1 complaint
In relation to NHTSA Recall Number: 23V342, Ford has failed to remedy issues around reverse Automatic Emergency Breaking. Whenever the 360° camera screen is blue, the system in place to prevent collisions also fails. There is no pattern of failure. Nearly 60% of the time the vehicle is driven an error related to 23V342 occurs.
Oct 26, 2023
ELECTRICAL SYSTEM,UNKNOWN OR OTHER,LANE DEPARTURE
1 complaint
I do realize there is a Recall for Back-up camera; which I've had issues with since early part of 2022 (we bought vehicle in April 2021). March of 2022 we had our suv to dealership about screen turning blue; which they supposedly did some deprogramming. Then, in July of 2022 had it back to dealership because the blue screen became worse; in which they said they replaced the whole system ( I have receipts/documents to prove this). Well, now when in Reverse we have blue screen or black. Occasionally when in drive while driving or sitting idling the screen either is blue, black or completely freezes to where none of options such as Navigation, hands-free calling, or anything can be done/used. I have video footages, I have pictures and the matter is only getting worse! I have called Ford Corporation, I have taken the suv recently to local dealership and just keep being told that all that is connected to back-up camera; THAT THERE IS NOTHING THEY CAN DO!! The Ford Explorer has had many electrical issues ranging from 3rd row seat (have receipt/documentation of this), to at times air/heat not wanting to work. Plus, it has had oil leak coming from front CV axle (have receipt/documentation of this). Anymore the local Ford dealership gives me the run around about repairs it seems to keep me coming back to pay for diagnostic repairs. Ford Corporation when I call them puts me on several holds while they "supposedly" call local dealership about the issues (Ford Corp acting like they don't know nothing). In addition I ve found out that all Services, repairs aren't being reported as required by law to do. I tried to upload my videos/media of the suv but it wouldn't upload to this website. If there is a specific email I could send the videos/media footage, the receipts/documents I'd do it immediately!! So, "please" let me know if there is an email!!
Oct 16, 2023
Chest Clip, Buckle, Harness
1 complaint
It is extremely difficult to tighten the harness on this seat. As we have used the seat more, the harness has gotten nearly impossible to get snug enough to be safe. I am a CPST, so I am sure the seat was adjusted properly for my child. I also talked to a CPST at Britax to make sure I wasn’t missing something that could help. I was sent a new harness to see if it would help, but it did not make any difference. We have since stopped using this car seat and replaced it.
Oct 06, 2023
STEERING,ELECTRICAL SYSTEM
1 complaint
The contact owns a 2021 Ford Explorer. The contact stated while driving approximately 60 MPH, the vehicle lost power steering functionality. The contact stated that prior to the failure she observed a "transmission code" warning that flashed twice but did not illuminate again. The contact pulled off the roadway and stopped the vehicle. The vehicle was restarted and regained power steering functionality. Additionally, the instrument cluster failed to operate as needed. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that a software update was needed. The vehicle was repaired. The contact stated that the instrument cluster failure reoccurred. The manufacturer had not been informed of the failure. The failure mileage was approximately 23,000.
Sep 08, 2023
POWER TRAIN,ELECTRICAL SYSTEM,UNKNOWN OR OTHER
1 complaint
I bought a new Ford Explorer XLT in 2021. I was driving with my kids on highway 101 at 70mph on 08/13/2023, wrench symbol came up and car speed immediately dropped down from 70mph to 30mph. Luckily the driver behind was very attentive and an accident was avoided and we were saved. After that car went into limp mode and had to be towed away. My car just have over 13k miles on it and is under every warranty. This wrench warning lamp came once on 07/31/2023 without impacting vehicle speed. I took the car to Ford dealership for inspection on 08/01/2023. After 3 days of inspection they said some sensor needs to be replaced which they don't have in inventory and will call me back when it is available. They handed over car to me telling it is totally safe to drive as they don't see any issue with driving. Now when I told the dealership about the harrowing experience they turned a deaf ear and said we will look into it without even caring to provide an answer. I insisted on providing a loner vehicle as they dont have a timeline on fixing the issue.I trusted the ford mechanics and ended up paying towing expenses for over 100 miles and best of all luckily survived. Me and my family are still in this shock.
Aug 14, 2023
ELECTRICAL SYSTEM,BACK OVER PREVENTION
1 complaint
Screen is blue by reverse
Aug 13, 2023
ELECTRICAL SYSTEM,LANE DEPARTURE,BACK OVER PREVENTION
1 complaint
Every 6 months, the rear cameras, cross traffic sensors and blind spot warning go out and completely stop functioning. I take it to the dealer tland they keep it for 1-2 weeks and eventually replace a fuse and send it home. This has happened four times. No one will actually correct the root cause ti the issue. It's going on its third week in the shop this time.
Jul 22, 2023
POWER TRAIN,ELECTRICAL SYSTEM,VISIBILITY/WIPER
1 complaint
Numerous times over the recent 2 months, I have experienced different issues with my 2021 Ford Explorer. The vehicle was purchased used in 2022 with less than 10,000 miles on it. It currently has 36k miles. When the vehicle is stopped but in drive and then accelerated to merge into traffic, the vehicle stalls and will not engage. The accelerator has to be pressed repeatedly to get the vehicle to begin moving again. This can take anywhere from 2-3 presses and 10-20 seconds. This creates a hazard for moving traffic and a safety issue. This occurs repeatedly with no warning beforehand. The vehicle has no lights to reflect an issue. Additionally, while the vehicle has been parked and shut-off, the electronics will turn on. On two separate occasions, the lights have turned on on their own and the radio has done the same; there was nobody in the car either. Over the past weekend, while driving down the road, no rain or water on windshield, and the wipes started. The vehicle persistently has a blue screen during backup. There is a concern for the electronics as a whole with all of the issues occurring. When accelerating on the highway/interstate, often times, an odd smell can be sensed, as if the EcoBoost is not functioning appropriately. The recall for rear axle bolt was repaired by Ford in Yukon, OK, and was informed that is the only recall currently with a repair available. The vehicle is available for inspection, as necessary.
Jun 26, 2023
UNKNOWN OR OTHER,BACK OVER PREVENTION
1 complaint
I am reporting countless incidences of my backup camera screen going to black or blue when the Gear Shift is selected to REVERSE. This has happened multiple times a day, week, month, etc. and is extremely frustrating. I am reporting in hopes to do anything I can to get the software fix expedited because it has been occurring for too long without a fix. t=The only "FIX" (if you can even call it that) for this problem is to stop what you are doing, put your car in PARK, turn the car OFF, open the driver's door to "reset", and then turn your car back on AGAIN in HOPES that the backup camera / 360 view is back to functioning within normal limits. That is unacceptable!!! It is not safe and anyone experiencing this issue should not have to stop their car, open a door, and restart it just to get the backup camera to work. I have contacted my dealership, Ford Corporate Offices, and now you guys in hopes to get this process going and the software to be fixed. Thank you - please contact for any questions or more information.
Jun 05, 2023
SERVICE BRAKES, AIR
1 complaint
The contact owns a 2021 Ford Explorer. The contact stated while driving 30 MPH and attempting to slow down, the vehicle failed to properly respond. The contact desperately depressed the brake pedal, but the vehicle failed to respond. The contact activated the parking brake, and the vehicle was able to stop. The contact was able to drive back to the residence. The vehicle was towed to the dealer and the dealer stated that the ABS module needed to be replaced. The vehicle was repaired but the failure persisted. The vehicle was taken to the dealer and the dealer stated that the wiring harness needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, and a case was filed. The failure mileage was 20,000.
Apr 27, 2023
POWER TRAIN,UNKNOWN OR OTHER
1 complaint
Car rolled down driveway while in park three separate times. Could have killed someone.
Apr 15, 2023
POWER TRAIN,ELECTRICAL SYSTEM,SERVICE BRAKES
1 complaint
After receiving a Ford issued recall for a potential rear axle bolt fracture, the dealer reprogrammed the PCM per Ford's reported repair solution. After this PCM update, the vehicle would randomly slam to a complete stop while driving. It happened several times with 3 different drivers (myself, my wife, and my son), each happening at 30-35 mph or less. It was usually preceeded by an audible clicking sound, but not always. We took the vehicle to the dealership several times, but they said they were not able to reproduce the issue, and continually returned the vehicle to us despite our grave concern for high risk of crash and injury. We even contacted Ford's customer service and legal departments several times, who ultimately refused to allow us to continue using a loaner vehicle and demanded that we return the loaner and retake possession of our Explorer because they said they had not received any other similar complaints, and their field engineer could not reproduce the issue and cleared the vehicle as safe, although Ford was never able to supply us with service records proving the repairs they purported despite our repeated inquiries. Ultimately, the issue happened again, and slammed while driving down a hill at about 40-50 mph, but this time the slamming was immediately followed by seemingly disengaging the drivetrain and causing the vehicle to roll downhill with no ability to accelerate, ultimately causing me to roll into a utility pole. Ford has since repurchased the vehicle, but given the severe safety risk associated with this issue and Ford's poor handling of our situation, I wanted others and the NHTSA to be aware in case other similar issues are reported in a effort to protect others from potential injury, especially in light of the increasing number if PCM-related issues and recalls reported against Ford...one of which was a PCM recall pertaining to our reported issue, but was not issued until after our repurchase was complete.
Apr 15, 2023
UNKNOWN OR OTHER,EQUIPMENT
1 complaint
Issue with navigation system. Many times is shows no GPS. Navigation does not always recognize current vehicle position and many times navigation does not even work. On many occasions, upon starting the vehicle, the clock does not even work when the navigation system isn't being used. This is a safety issue when we are traveling out of town. We are not fans of using our phones for navigation as an alternative to the faulty vehicle onboard navigation. This first started happening December 2022.
Feb 17, 2023
VEHICLE SPEED CONTROL,ENGINE
1 complaint
On or about 9 am on Tuesday, January 10, 2023, I entered a parking garage facility and drove up the ramp and continued on a level parking area and begin to turn into a parking space beside a large cement column. Just as I entered the parking space at a low rate of speed without my foot on the accelerator, I experienced sudden unintended acceleration which caused the vehicle to narrowly miss the cement column and the front cement wall of the parking space. Fortunately, I quickly braked to avoid a collision and then put the vehicle in park and shut off the vehicle. There were no warning lights on the vehicle dash, and I have not yet taken the vehicle to an authorized Ford Dealer to have it checked. Vehicle is still under factory order and has approx. 26,700 miles.
Jan 10, 2023
PARKING BRAKE
1 complaint
The contact owns a 2021 Ford Explorer. The contact stated that he recently had a manufacturer recall performed on the vehicle for Ford Customer Satisfaction Program Number 22N06 (Rear Axle Bolt Replacement). The contact stated that the dealer re-programed the E-brake to engage automatically when the vehicle was placed in park(P). The contact stated while reversing out of his driveway the vehicle would not move. The contact had been instructed to tap on the accelerator to release the E-brake. The contact stated that the RPM was raised to approximately 2,000 RPM, and only then would the high RPM release the E-brake; however, the vehicle would lurch into motion at approximately 10 MPH. The contact stated that the E-brake warning light was illuminated and then switched off once the E-brake was disengaged. The contact stated that the failure was more pronounced while reversing on a slope. The contact stated that the failure recurred while placing the vehicle in drive(D) however, the vehicle lurched and jumped forward. The contact stated that the motion was not as aggressive as while the vehicle was in reverse(R). The contact had taken the vehicle back to the local dealer where it had been reprogrammed. The contact was advised that all that could be done was to reprogram the E-brake. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 23,000.
Dec 27, 2022
POWER TRAIN,SERVICE BRAKES
1 complaint
The contact owns a 2021 Ford Explorer. The contact stated that he had received a recall notification for NHTSA Campaign Number: 22V255000 (Power Train). During a routine maintenance check, the recall was serviced; however, upon return of the vehicle, the brake pedal was depressed to the floorboard with the parking brake fault, uphill assist, and ABS warning lights illuminated. The contact also stated that while driving at various speeds, the brake pedal hardened and the vehicle failed to stop as needed. The contact's wife called the dealer and was informed that there were 5 other vehicles that had experienced the same failure. The contact attempted to reach the manufacturer but was unsuccessful. The vehicle was not repaired. The failure mileage was approximately 37,000.
Sep 06, 2022
ENGINE,FUEL/PROPULSION SYSTEM
1 complaint
Gear(transmission), when put in reverse the car goes forward instead of reverse, and Jerks in reverse after 7-15 sec. And it also jerks while accelerating.
Jun 23, 2022
AIR BAGS,VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE
1 complaint
The contact owns a 2021 Ford Explorer. The contact stated the adaptive cruise control and the collision avoidance systems would malfunction. The vehicle would suddenly deactivate the cruise control and the collision avoidance would detect a non-existing object and stop the vehicle from also turning to avoid the crash. The contact stated that while idled at a stop light when the vehicle suddenly accelerated rear-ending the vehicle in front. The air bags did not deploy however the acceleration did not reach high enough speeds for such a response. A police report was not filed. The vehicle was not towed. There were no injuries or medical attention needed. The contact took the vehicle to the dealer however the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failures. The approximate failure mileage was 10,000.
Jun 15, 2022
UNKNOWN OR OTHER,SERVICE BRAKES
1 complaint
While in a driveway at a decline (approximately 5% grade), I placed the vehicle in park and set the emergency brake; when I decompressed the brake to turn the vehicle off it took off sliding down the street. A coworker was with me and was about to get out at the time as well. Fortunately I was able to gain control before I hit the mailbox in front of us and no one or thing was injured This was the second time this happened; however, the first time the emergency brake was not set. Also, starting at 23k miles, I am repeatedly getting a "Auto Hold system fault" error every few days. This occurs sometimes at startup and sometimes while driving and the Auto Hold will not work when it comes up. However, if I stop and restart the vehicle, it will go away and work. I am not sure these are related.
Jun 04, 2022
FUEL SYSTEM, GASOLINE,BACK OVER PREVENTION
1 complaint
Since purchasing this vehicle I have off and on experienced my bluetooth echoing for the party on the other end of the line. I have also experienced my gas tank shaking my entire car upon stopping depending how much gas is in the tank, usually full to 3/4 full. I have also experienced on multiple occasions my back up camera turning blue. There was a trend going for a while if it was hot outside it would turn blue all the time. However, over the winter months it periodically started changing blue. More recently, when I put my car into reverse it will take a few seconds to switch gears. I also experienced my front driverside window not going up. I had to turn the car off and back on again in order for it to go back up. Altogether, I have had multiple issues with my brand new car since the day of purchase. I immediately took the vehicle back in for the gas tank shaking and their response was because I was not used to driving a "smaller" car. I however find that extremely unsafe in the event I were to break too hard, I feel that my gas tank would come disassembled.
Apr 08, 2022
STRUCTURE,WHEELS
1 complaint
On October 25, 2021; my wife and I were driving across country when we experienced a blow-out at 75 MPH in New Mexico (about 80 miles west of Amarillo. The blow-out was caused by body cladding, which came off the right rear door of our 2021 Ford Explorer - apparently attributable to 19+ MPH desert cross winds at highway speeds of 75 MPH. The trim lodged in the right rear wheel well; slicing the tire and cutting a gash from the aluminum rim. We had to get to California for a scheduled closing on our new home and were therefore unable to stay in Amarillo or Albuquerque for the three days required to receive a matching rim and tire, so I had a nearby tire store install a wheel of a different size with an offsetting tire size to approximate the circumference of the stock wheels and tires. Ford has thus far neglected to acknowledge the obvious defect that would allow a body part to blow off the car and has offered no assistance in repairing the car or reimbursing me for the wheel and tire I had to purchase to meet personal legal obligations. I've seen evidence in online forums indicating other incidents of body trim blowing off Ford Explorers at highway speeds. Ford must take responsibility for this defect and reimburse other owners and me for costs incurred to resolve implications of their defective body parts.
Dec 09, 2021
STEERING,TIRES
1 complaint
The front tires chewed to pieces, one blew, and the dealer initially felt it was an alignment issue from the factory. Up one further inspection, they found an aluminum toe rod with a 45 degree bend. I believe this was a factory issue as we hit nothing on the highway. It seems from an FMEA point of view, it is likely the blown tire and momentum of the car bent the tie rod and that the tire damage was caused by a part failure or some other issue with the car. It is a 3 month old car with 9,400 miles. The car struck Nothing on the highway.
Jun 24, 2021
POWER TRAIN,ELECTRICAL SYSTEM,FORWARD COLLISION AVOIDANCE
1 complaint
I PURCHASED A FORD EXPLORER ST 2021 IN NEW YORK FROM CITY WORLD FORD ON BOSTON RD IN THE BRONX ON APRIL 22, 2021 AT APPROXIMATELY 9:37PM. I TOOK MY CAR HOME THE SAME SAME DAY. THE FOLLOWING DAY (SECOND DAY) I STARTED EXPERIENCING A PRE-COLLISION ASSIST NOT AVAILABLE AND POWERTRAIN MALFUNCTION/REDUCED POWER LIGHT ON MY DASHBOARD AT 12:49 PM. THE CAR BEGAN TO JERK AND FELT LIKE IT WAS ON AWD MODE. THE GAS PEDAL WAS HEAVY AND DIFFICULT TO DRIVE WHILE I WAS ON THE HIGHWAY WITH MY CHILDREN. I STARTED TO SMELL FIRE COMING FROM THE INSIDE OF MY CAR. ONCE I STARTED EXPERIENCING THOSE PROBLEMS FROM MY CAR I IMMEDIATELY PARKED THE CAR. I IMMEDIATELY CALLED THE DEALERSHIP DIDN'T GET AN ANSWER SO I DROVE TO THEM PERSONALLY AFTER I LET IT COOL DOWN FOR A COUPLE OF HOURS. I EXPLAINED THE PROBLEM I EXPERIENCED WITH THE CAR TO THEM. THE DEALERSHIP STATED TO ME TO TAKE IT TO THE REPAIR SHOP THE MONDAY AND I DID. THE NEXT DAY (TUESDAY) I PICKED UP THE CAR FROM REPAIR SERVICE CENTER. THE NEXT DAY I STARTED EXPERIENCING THE SAME PROBLEMS WITH THE FORD. I WENT BACK TO THE DEALERSHIP ON WEDNESDAY (NEXT DAY) AND STATED I WANTED A NEW CAR OR EXCHANGE FOR A DIFFERENT CAR. MANAGER STATED I HAD TO TAKE THE CAR FOR SECOND TIME FOR REPAIR. I THEN TOOK THE CAR FOR THE SECOND TIME FOR REPAIR ON WEDNESDAY. THE CAR IS CURRENTLY STILL IN THE REPAIR SERVICE CENTER AND STILL DISPLAYING MALFUNCTIONS AFTER BEING REPAIRED IN THE REPAIR SERVICE CENTER. I HAVE NOT YET RECEIVED MY CAR BACK AND REPAIR CENTER STATED THEY ARE NOT SURE WHEN WILL THE PROBLEM WILL BE FIXED AND WORKING PROPERLY.
May 01, 2021
STEERING,SUSPENSION,WHEELS
1 complaint
THE WHEEL WELLS OF THE VEHICLE COLLECT LARGE AMOUNTS OF SNOW AND ICE. THIS BUILD UP CONSTRICTS THE WHEELS OF THE VEHICLE CONTACTING THE TIRES RESTRICTING ROTATION AND STEERING. THIS IS AN EXTREMELY DANGEROUS POTENTIALLY DEADLY SITUATION. WE HAVE CONTACTED FORD MOTOR COMPANY AND THE DEALERSHIP. NO REMEDY TO THIS SITUATION HAS BEEN OFFERED. PLEASE INVESTIGATE AND ANY ASSISTANCE IS APPRECIATED. I BELIEVE THIS IS A WIDE SPREAD PROBLEM FORD IS UNWILLING TO DEAL WITH. THIS CONDITION OCCURS IN COLD WEATHER AND SNOWY ICY CONDITIONS. THE BUILD UP HAZARD HAPPENS EVEN DRIVING SHORT HIGHWAY DISTANCES.
Mar 20, 2021
Frequently Asked Questions
How many problems does the 2021 FORD Explorer have?
The 2021 FORD Explorer currently has 336 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.
What are the most common problems with 2021 FORD Explorer?
The most common problems reported for the 2021 FORD Explorer are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.
Where does this 2021 FORD Explorer problem data come from?
All problem and complaint data for the 2021 FORD Explorer comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.
Other Years - FORD Explorer
2025 Problems
2024 Problems
2023 Problems
2022 Problems
2020 Problems
2019 Problems
2018 Problems
2017 Problems
2016 Problems
2015 Problems
2014 Problems
2013 Problems
2012 Problems
2011 Problems
2010 Problems
2009 Problems
2008 Problems
2007 Problems
2006 Problems
2005 Problems
2004 Problems
2003 Problems
2002 Problems
2001 Problems
2000 Problems
1999 Problems
1998 Problems
1997 Problems
1996 Problems
1995 Problems
1994 Problems
1993 Problems
1992 Problems
1991 Problems
1990 Problems
Other FORD Models
'34
1500 Foldaway
A8513
A9513
A9522
Aerostar
Affordable Aluminum
Affordable Trailers
Aspire
AT8513
AT9513
AT9522
Similar Brands
ST
3,555 models
RS
3,484 models
NC
2,822 models
ND
2,385 models
Z
1,951 models
MOTO
1,583 models
NU
1,189 models
RC
1,122 models