2005 FORD F-250 Problems

VIN Decoder

Premium Report

144

Complaints Reported

Radar Detector GPS Tracker OBD2 Scanner Car Refrigerator Jump Starter Dash Cam

As an Amazon Associate, ForCar.org earns from qualifying purchases.

Complaints by Component

ENGINE

17 complaints

The contact owns a 2005 Ford F-250. The contact stated while driving at an undisclosed speed, the contact heard a loud rumbling noise that sounded like rocks in the engine. In addition, the contact stated that when the vehicle was parked and the engine was turned off, the vehicle was started, however, the vehicle did not start. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact stated that her husband was an independent mechanic and had recently replaced several unknown parts, however the failure reoccurred. The manufacturer was not made aware of the failure. The failure mileage was 246,808.

Oct 15, 2024

ENGINE WOULD PUT OUT WHITE SMOKE THEN WOULD START TO OVER HEAT.

Mar 01, 2019

THIS PARTICULAR MODEL AND YEAR WITH THE 6.0 LITRE ENGINE (2005 ) IS NORTORIOUS FOR THE OIL COOLER TO BLOW UP LEAVING YOU STRANDED WHEREVER. WHEN IT HAPPENED TO ME I WAS PULLING A 33FT 5TH WHEEL TRAILER AND ALMOST WRECKED. FORD KNOWS ALL ABOUT THIS FAULTY PIECE OF EQUIPMENT YET DOESN'T RECALL IT AND SHOULD BE HELD ACCOUNTABLE FOR REPLACING IT. IT COST ME $6000 TO GET MY TRUCK FIXED. THE FAULTY PIECE WAS INSTALLED BY FORD AND SHOULD BE RESPONSIBLE BY FORD FOR REPAIR COSTS

Aug 06, 2018

TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A COMPLETE LOSS OF POWER WHILE DRIVING VARIOUS SPEEDS. THE FAILURE OCCURRED WITHOUT WARNING. FERRARIO FORD LINCOLN (2472 CORNING RD, ELMIRA, NY) WAS CONTACTED AND DIAGNOSED THE FAILURE AS A HIGH PRESSURE OIL PUMP MALFUNCTION AND THE PART WOULD NEED TO BE REPLACED. THE FAILURE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 20,000.

May 09, 2018

TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING 25 MPH, THE ENGINE STALLED AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE LOST POWER, ROLLED BACK DOWN THE HILL, AND STOPPED. THE VEHICLE WAS TOWED ON DECEMBER 10TH TO LEGACY FORD (2906 ISLAND LAGRANDE, OR 97850). THE DEALER STATED THAT THERE WERE NO RECALLS ON THE VEHICLE FOR THE FICM. THE DEALER MADE TWO REPAIRS DUE TO AN UNKNOWN RECALL REGARDING THE PRESSURE SENSOR AND RECALIBRATION. THE MANUFACTURER WAS CONTACTED AT 1-800-392-3673 AND STATED THAT THERE WERE NO RECALLS ON THE FICM FOR THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED DUE TO NOT BEING ABLE TO REGAIN POWER. THE VEHICLE HAD NOT BEEN REPAIRED AND REMAINED AT THE DEALER. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 205,000.

Dec 14, 2017

+ 12 more complaints for this component

SUSPENSION

17 complaints

The contact owns a 2005 Ford F-250. The contact stated while driving approximately 75 MPH, the front suspension started to bounce and vibrate, causing the vehicle to shift independently to the right lane. The contact stated no warning light was illuminated. The contact slowed the vehicle and the failure stopped. The contact had not taken the vehicle to a local dealer or independent mechanic to be diagnosed. The vehicle had not been repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 150,000.

Aug 25, 2022

The steering is extremely lose and has a shimmy or “death wobble” when going over any type of bumps or other issues and at speed on the highway. Similar to recall 09L02

Oct 23, 2021

MY 2005 FORD F250 SUPER DUTY TRUCK EXHIBITS A CONDITION REFERRED TO IN FORUMS AS 'DEATH WOBBLE', IN WHICH THE TRUCK'S FRONT SUSPENSION SHAKES VIOLENTLY AT HIGHWAY SPEEDS ABOVE 50 MPH. THIS CONDITION IS GENERALLY BROUGHT ON BY EITHER OF THE FRONT WHEELS HITTING ANY DEVIATION IN THE ROAD SURFACE SUCH AS BRIDGE EXPANSION JOINTS, POTHOLES, ETC. THE CONDITION IS SO BAD THAT IMMEDIATE LOSS OF CONTROL CAN ONLY BE CONTROLLED BY JERKING OF THE STEERING WHEEL OR AN IMMEDIATE REDUCTION IN SPEED, GENERALLY TO 25 MPH. I HAVE EXPERIENCED THIS CONDITION SEVERAL TIMES OVER THE PAST 9 YEARS SINCE PURCHASING THIS VEHICLE, MOST RECENTLY ON JULY 12TH WHILE TRAVELING ON THE 57 FREEWAY IN SOUTHERN CALIFORNIA AT 65 MPH. I WAS TRAVELLING IN THE LEFT HAND LANE NEXT TO THE CARPOOL LANE (IN MODERATE TRAFFIC) WHEN I ROLLED OVER A BRIDGE EXPANSION AND THE LEFT FRONT WHEEL STARTED SHAKING VIOLENTLY AND CAUSING ME TO IMMEDIATELY APPLY MY BRAKES TO REGAIN CONTROL. THE SEVERITY SEEMS TO BE GREATLY REDUCED WHEN HAULING A SUBSTANTIAL LOAD IN THE TRUCK BED, BUT I DID EXPERIENCE THIS TWICE WHILE HAULING A 20' CARGO TRAILER ACROSS THE COUNTRY. I UNDERSTAND THAT A CLASS ACTION SUIT WAS FILED AGAINST FORD IN JUNE/2019 AND THAT FORD HAS BEEN AWARE OF THIS ISSUE WITH OTHER TRUCK OWNERS FILING COMPLAINTS REGARDING THIS CONDITION. I PERSONALLY HAVE NOT GONE TO FORD REGARDING THIS AS IT IS A WASTE OF MY TIME. THE COMPONENTS THEY REPLACE DO NOT CURE THE PROBLEM, AS MANY TRUCK OWNERS WILL ATTEST. IN MY RESEARCH, I FOUND A COMPANY IN UTAH THAT PROVIDES AN AFTERMARKET KIT THAT APPEARS TO FIX THE ISSUE. AS I AM ABOUT TO EMBARK ON ANOTHER 6000 MILE JOURNEY WITH MY WIFE AND FAMILY, I INTEND TO PURCHASE AND INSTALL THIS KIT ON MY VEHICLE. IF I FIND UPON RETURNING THAT THIS KIT HAS ALLEVIATED MY TRUCK'S ISSUE, I WILL RE-CONTACT NHTSA WITH MY RESULTS.

Aug 26, 2019

HIT A BUMP GOING ACROSS A BRIDGE ON I-74. THE ENTIRE TRUCK BEGAN TO SHAKE VIOLENTLY FOR SEVERAL HUNDRED FEET BEFORE I REGAINED CONTROL OF THE VEHICLE. THIS IS EVIDENTLY WHAT FORD IS CALLING A " SHIMMY" . I HAD ALMOST NO CONTROL OF THE VEHICLE AT THIS POINT. IF THE SHOULDER OF THE HIGHWAY WAS ANY NARROWER I WOULD NOT BE HERE TODAY. THIS HAPPENED AGAIN TWO DAYS LATER. I WAS ALMOST REAR ENDED AT A SPEED OF 60 MPH. I DON'T KNOW WHAT TO DO, I'M STILL MAKING PAYMENTS ON A TRUCK THAT IS UNSAFE TO DRIVE. THIS "SHIMMY " IS GOING TO GET PEOPLE KILLED. *TR

Jun 02, 2014

TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT THE FRONT END OF THE VEHICLE WOULD SHAKE WHENEVER HE DROVE OVER A BUMP. THE FAILURE OCCURRED AT ALL SPEEDS. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED. THE CONTACT REPLACED THE TIRES HIMSELF, BUT THE FAILURE CONTINUED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 12,000.

Dec 14, 2011

+ 12 more complaints for this component

STEERING,SUSPENSION

14 complaints

While driving at 65 Mph, towing a fifth wheel camper, encountered a mildly rough section of highway when entire front end began to wobble and shake violently. Slowed the vehicle, maintaining control. When going back up to speed, the same shaking occured again. Also noted a less violent shaking at 45 mph. Took vehicle to have new tires rebalanced but did not change condition much. Inspected front end components. Currently replacing steering damper and shocks in hopes of correcting issue. All other components new or nearly new (3 years) with no issues. Vehicle and components can be inspected, and all replaced parts will be kept for inspection if required. Safety of my vehicle and others on busy highway could have been compromised had I not slowed and maintained control. The problem is being dealt with by me, as I do most maintenance on vehicle. The vehicle has not been seen or inspected by others except by tire mechanic who noted no obvious issues but did re-balance all tires. There was NO advance warning of a failure or compromise.

Jan 15, 2025

towing a trailer, traveling at 70 mph, I hit a pothole and vehicle violently shook. The episode lasted for approx 30 seconds. It was very Difficult to maintain control and I almost ran off the road. It happened several times before I took it for repairs. The stabilizer bar was replaced, however the violent shaking has still continued.

Sep 27, 2022

Front end suspension shimmy> My granddaughter and I were driving at 60mpa and hit a bump and could not control shaking of truck until pulling over to stop. This happened without warning. Had to drive back roads to get home.

Aug 27, 2022

Driving on the freeway at apps 65 miles per hour, the truck hit a numb in the road and started to shaking causing the truck to shake violently. I was able to get to the side of the road and slow down which eased the shaking. I started driving again and after reaching speeds this happened two more times, then I got off the freeway and drove backroads home under 40 miles per hour.

Nov 11, 2021

A SCARY AND SERIOUS WOBBLE AT 35 MPH. HAD TO CREEP HOME. ALMOST LOST CONTROL.

Apr 16, 2021

+ 9 more complaints for this component

STEERING

14 complaints

THE FORD 250 INITIATES A 'DEATH WOBBLE' OR INTENSE SHIMMY IN THE FRONT WHEELS AT SPEEDS GREATER THAN 50 MPH ANYTIME ANY SMALL BUMP IS ENCOUNTERED ON ROAD. THIS INSTANCE INITIATED 5 TIMES IN A 500 MILE HIGHWAY TRIP AT SUCH AN INTENSE RATE THAT THE VEHICLE LOST SIGNIFICANT STEERING CONTROL AND HAD TO BE IMMEDIATELY DECELERATED TO NEARLY 20 MPH FOR IT TO STOP. INITIAL SPEED WAS CLOSE TO 63 MPH. THE SHIMMY INITIATED WHEN A SMALL BUMP IS PASSED OVER AND ON THREE OF THESE INSTANCES IT INITIATED WITH THE CROSSING OF A EXPANSION GAP OR TRANSITION FROM THE HIGHWAY TO A BRIDGE OR BRIDGELIKE STRUCTURE. THE WOBBLE SHOOK TRUCK SO MUCH THAT DIRECTIONAL CONTROL WAS LOST. APPROACHING (TRAFFIC FROM THE REAR) HAD TO SWERVE OUT OF THEY WAY TO AVOID A REAR COLLISION. IF DECELERATION IS NOT IMMEDIATELY IMPOSED THE VEHICLE MAINTAINS THE SHIMMY AND DIRECTIONAL CONTROL IS SEVERELY COMPROMISED. IN TWO INSTANCES ON THIS TRIP I WAS ABLE TO NURSE THE WOBBLING VEHICLE OFF THE ROAD TO THE SHOULDER TO THEN BRAKE TILL CONTROL COULD BE RETRIEVED. HOWEVER, THERE ARE MANY INSTANCES WHEN ACCESS TO THE RIGHT SIDE IS IMPEDED SUCH AS WHEN PASSING IN LEFT LANE. THE SAME ISSUE HAS HAPPENED BEFORE ON A HIGHWAY TRIP TO ANOTHER STATE 6 MONTHS BEFORE.

Mar 03, 2020

ON MY 2005 FORD DIESEL F250,AFTER 126000 MILES, STEERING BECAME VERY LOOSE. HAD ENTIRE FRONT END REPLACED INCLUDING GEAR BOX. REBUILDER PURCHASED MOTOCRAFT REBUILT STEERING BOXES FROM FORD. FOUR OF THESE REBUILT BOXES WERE TRIED ON THE TRUCK. NONE WERE ANY GOOD. BUILDER SAID THAT THIS WAS A COMMON PROBLEM WITH FORD GEAR BOXES. THEY INDICATED THAT THE GEAR BOX REBUILDERS ONLY REPLACED THE BEARINGS, NOT THE WORN-OUT GEARS WITHIN THE BOX. THE FORTH GEARBOX INSTALLED WAS EVEN WORSE, IT WAS DANGEROUS. WHEN DRIVING ON THE FREEWAY THE TRUCK WOULD VEER WITHOUT WARNING INTO ANOTHER LANE AND WOULD BE VERY DIFFICULT TO CORRECT. THE TRUCK IS BACK IN THE SHOP AGAIN. THIS TIME TO BUY AN AFTER MARKET (NON FORD) GEAR BOX. THIS VEHICLE'S FRONT END PROBLEM HAS SO FAR COST ME OVER $4000. IN REPAIRS, BUT , WHAT IS WORSE THESE GEAR BOX REPLACEMENTS COULD CAUSE AN ACCIDENT.

Mar 05, 2016

TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 55 TO 60 MPH, A POT HOLE WAS HIT AND CAUSED THE VEHICLE TO SHIMMY AND SHAKE OUT OF CONTROL. THE BRAKE WAS ENGAGED WHILE AT HIGHWAY SPEEDS TO BRING THE VEHICLE UNDER CONTROL. THE DEALER ADVISED THAT THE TIE RODS FAILED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 97,000.

Jan 31, 2013

I STARTED THIS TRIP AT THE KENTUCKY HORSE PARK, I-75 AT EXIT 120. I HAD BEEN DRIVING AN HOUR, HEADING NORTH. THIS INCIDENT TOOK PLACE LATE AFTERNOON, BETWEEN 5PM AND 6PM, BROAD DAYLIGHT EXCELLENT VISIBILITY, DRY, PARTLY CLOUDY, TRAVELING 65 MPH IN THE CENTER OF THREE LANES. I WAS NOT TIRED NOR DISTRACTED. I WAS NORTHBOUND ON I-75 IN NORTHERN KY WHEN I WENT OVER A MINOR BUMP, JUST ROUGH PAVEMENT. I AM ABSOLUTELY CERTAIN THERE WAS NO OBJECT IN THE ROAD. AFTER THE BUMP THE TRUCK BEGAN STEERING ERRATICALLY, WANDERING, MUCH AS IT HAD 4 DAYS EARLIER WHEN I TOOK IT TO MY FORD DEALER AND THEY REPLACED THE FRONT U-JOINTS. I SLOWED DOWN, GOT THE TRUCK UNDER CONTROL, TURNED OFF THE CRUISE CONTROL, AND MOVED TO THE RIGHT LANE. I HEARD A HIGH-PITCHED SCREECHING METAL NOISE. THEN I SMELLED BURNING RUBBER. I WAS ALERT AND VERY AWARE OF ROAD CONDITIONS AND THE TRAFFIC (TWO LANES WERE MERGING FROM THE RIGHT FROM I-275 SO I WAS IN THE CENTER OF FIVE LANES) AND I AM CERTAIN THERE WERE NO OBJECTS IN THE ROAD. THE CONCRETE WAS CLEAR AND SMOOTH. I HEARD A LOUD BANG UNDER THE RIGHT FRONT OF THE TRUCK AND IT TOOK OFF TO THE RIGHT. IT WAS IMMEDIATELY CLEAR THE TRUCK WAS NOT RESPONDING TO THE STEERING WHEEL. I PUT BOTH FEET ON THE BRAKE PEDAL, MADE MY BODY RIGID AND PULLED UP ON THE STEERING WHEEL FOR MAXIMUM DOWN FORCE ON THE BRAKE PEDAL. COMPLETELY OUT OF CONTROL, I TRAVELED ACROSS BOTH LANES ON MY RIGHT (THE MERGING LANES FROM I-275) AND CAME TO A STOP WITH THE LEFT REAR WHEEL ON THE CONCRETE APRON AND ALL OTHER WHEELS IN THE ROCKY SOIL THAT WAS THE SIDE OF A DITCH WITH A MOUNTAIN ON THE OTHER SIDE. IT WAS LATER DETERMINED THAT THE TIE ROD END HAD SNAPPED. ONE THEORY IS THAT THE TIE ROD END WAS OVER-HARDENED AND BECAME BRITTLE, POSSIBLY CRACKED, THEN THE NEW U-JOINTS CHANGED THE STRESSES ON IT AND IT SNAPPED. INSURANCE REPORT, CRASH SITE AND PARTS PHOTOS AVAILABLE ON REQUEST. *TR

Sep 18, 2012

Crash: 1

TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT DROVE OVER A BUMP AND THE VEHICLE BEGAN TO IMMEDIATELY VIBRATE VIOLENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHERE BOTH FRONT TIE ROD ENDS WERE REPLACED. THE CONTACT ALSO RECENTLY RECEIVED AN ADVISORY NOTIFICATION LETTER FROM THE MANUFACTURER IN REGARDS TO STEERING WHEEL AND FRONT END VIBRATIONS WHEN DRIVING OVER BUMPY ROAD SURFACES. THE MANUFACTURER ADVISED OWNERS TO MAINTAIN PROPER TIRE INFLATION. THE MANUFACTURER WAS NOTIFIED AND MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 20.

Jan 04, 2012

+ 9 more complaints for this component

ENGINE AND ENGINE COOLING

13 complaints

TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 50 MPH THE VEHICLE STARTED TO JERK VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE DEALER COULD NOT DIAGNOSED THE PROBLEM. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 80,000.

Feb 27, 2012

TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE VEHICLE STARTED TO JERK VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE AND SENT A LETTER ADVISING TO CHECK THE TIRE INFLATION PRESSURE LEVEL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 110,000.

Feb 27, 2012

TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH WHEN THERE WAS A SLIGHT LOSS IN ENGINE POWER WITH AN UNUSUAL NOISE. THE FAILURE BECAME MORE SEVERE OVER A PERIOD OF TIME AND OCCURRED WHENEVER THE VEHICLE WAS IN OPERATION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO DETECTED COOLANT SEEPAGE WHICH CAUSED SUBSTANTIAL DAMAGE TO THE ENGINE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

Feb 17, 2012

THE ABOVE VEHICLE HAS HAD MULTIPLE PROBLEMS DUE TO THE DESIGN OF THE ENGINE INCLUDING SUCH THINGS AS THE EGR COOLER, THE EGR VALVE (TWICE), THE FUEL INJECTOR CONTROL MOD (FICM), THE HIGH PRESSURE OIL REGULATOR SCREEN, (A .10 CENT PIECE 450.00 LABOR). IF YOU WILL SEARCH THIS ENGINE FROM 2003 TO 2007 YOU WILL FIND HUNDRED IF NOT THOUSAND OF POST BY OWNERS OF THE 6.0 POWERSTROKE THAT ARE HAVING THE SAME PROBLEMS OVER AND OVER. FORD REFUSES TO DO ANYTHING TO HELP ANYONE AND THEY TOLD ME IN AN EMAIL YOU WERE THE ONLY ONES THAT CAN MAKE THEM HAVE A RECALL. I HOPE YOU WILL STEP UP AND HELP ALL OF US. FORD FILED SUIT AGAINST THE MANUFACTURE (INTERNATION/ NAVISTAR) OVER THIS ENGINES PROBLEMS BACK IN 2004 BUT THEY KEPT SELLING IT KNOWING IT HAD PROBLEMS THAT WOULD BE LEFT UP TO THE BUYERS OF THE VEHICLES, I WAS PERSONALLY TOLD BY A SALESMAN TO EXPECT 350,000 MILES FROM THIS ENGINE. IF YOU CAN NOT HELP ME AND THE OTHERS CAN YOU TELL ME WHAT ELSE I CAN DO? WILL IT TAKE LEGAL ACTION OR IS THERE ANOTHER PATH I CAN TAKE? *TR

Feb 14, 2012

TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THE FUMES ENTER THE CABIN AND MAKE THE VEHICLE OCCUPANTS DIZZY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE BOLTS FOR THE ENGINE MANIFOLD CORRODED AND FRACTURED. THE DEALER STATED THAT THIS WAS A KNOWN FAILURE BECAUSE THE BOLTS WERE METAL AND THE FRAME WAS ALUMINUM. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 55,000.

Jan 04, 2012

+ 8 more complaints for this component

POWER TRAIN

7 complaints

Transmission has a hole in it. Linkage inside broke and caused hole on case. Can’t use item for a core due to this. Happened while driving home from just across town.

May 25, 2022

ON DECELERATION THE ENGINE STALLS AFTER DRIVEN FOR 10-15 MINUTES. THE CHECK ENGINE LIGHT COMES ON. I DON'T NOTICE THE STALL UNTIL I APPLY THE GAS PEDAL. A COUPLE OF TIMES I WAS TURNING, I HAD TO SLOW DOWN SEVERELY TO GIVE ME MORE TIME TO TURN( NO POWER STEERING). I ALMOST HAD AN ACCIDENT SEVERAL TIMES. THE CODE WAS A THROTTLE BODY CODE P2104.I REPLACED THE THROTTLE BODY. AFTER A FEW MONTHS THE STALLING OCCURRED AGAIN. THIS IS DANGEROUS. AT THIS TIME THE STALLING HASN'T HAPPEN VERY OFTEN BUT THE CODE IS STILL THERE, NOW I HAVE TO SMOG THIS VEHICLE. I SEE ON THE INTERNET THERE HAVE BEEN OTHER PEOPLE WITH THIS CONDITION.

May 27, 2019

TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD, PLACED THE GEAR IN NEUTRAL, RESTARTED THE VEHICLE, AND WAS ABLE TO RESUME DRIVING. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC (BOLAN TRANSMISSION SHOP) WHO DIAGNOSED THAT THE TRANSMISSION WAS BURNED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 85,000.

Jun 23, 2017

NOTICED A CLOUD OF SMOKE BEHIND VEHICLE WHILE DRIVING 55 MPH ON HIGHWAY. UPON INSPECTION FOUND IT WAS LEAKING TRANSMISSION FLUID FROM HOLE IN TOP OF TRANSMISSION ONTO EXHAUST (EXACT SAME PROBLEM AS DESCRIBED IN FORD BULLETIN 05B27) HAD TO REPLACE TRANSMISSION AT 57,265 MILES AT A COST OF $4,000.00. FORD WOULD NOT WARRANTY IT.

Dec 18, 2015

2005 FORD F250 SD HAD CRACKED TRANSMISSION BECUASE OF LOW/REVERSE SNAP RING FAILURE IN THE 5R110 TORQSHIFT TRANSMISSION. FORD ISSUED A CUSTOMER SATISFACTION PROGRAM 05B27 BUT PUT AN EXPIRATION DATE ON IT. THE PROGRAM WAS NOT EVER FOR A WHOLE YEAR. FORD IS NOT WILLING TO REIMBURSE OR ISSUE A RECALL WHEN THEY KNOW THIS IS A PROBLEM. THE SNAP RING FAILED INSIDE AND BUSTED MY TRANSMISSION. ALOT OF PEOPLE HAVE EXPERIENCED THIS PROBLEM AND THERE NEEDS TO BE A RECALL ON THIS TRANSMISSION. *TR

Jan 17, 2011

+ 2 more complaints for this component

SERVICE BRAKES

4 complaints

THE REAR BREAKS LOCK UP ON THE CALIPER PINS. THE CALIPERS AND PADS HAVE BEEN REPLACED UNDER WARRANTEE, AND THREE TIMES OUT OF POCKET. THE FORD DEALER NOW SAYS THE PROBLEM LIES IN THE CALIPER PIN, AFTER LOCKING UP BUY NEW PINS GREASE AND YOU ARE GOOD. THIS ONLY LAST UNTIL THE TRUCK SITS 3-5 DAYS. WHEN THE BREAKS LOCK UP THE REAR BREAK ARE HOT ENOUGH TO CATCH ON FIRE AND THE STOPPING ABILITIES ARE IMPAIRED. YOU LOOK ON THE INTERNET AND THIS IS A VERY COMMON PROBLEM WITH THE SUPERDUTY FORDS. THERE IS NO FIX AVAILABLE. WE ARE AFRAID TO DRIVE THE VEHICLE BECAUSE YOU NEVER KNOW WHEN THEY WILL LOCK. YOU MAY DRIVE TO TOWN FINE BUT ON THE WAY HOME IT IS LOCKED AND DANGEROUS.

Mar 11, 2018

TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT THE SPEEDOMETER ABNORMALLY FLUCTUATED. THE VEHICLE BRIEFLY STALLED DUE TO THE ABS INDEPENDENTLY APPLYING THE BRAKES. THE ABS WARNING INDICATOR ILLUMINATED, BUT THE FAILURE ALSO OCCURRED WITHOUT THE WARNING INDICATOR. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 35,000.

Jul 25, 2016

TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING 60 MPH, THE FRONT DRIVER SIDE BRAKES OVERHEATED AND SEIZED. THE FRONT END OF THE VEHICLE JERKED VIOLENTLY WHEN THE FAILURE OCCURRED. THE DEALER STATED THAT THE FRONT DRIVER SIDE BRAKES NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 41,575. UPDATED 10/28/2014*LJ THE CONSUMER STATED THE VEHICLE HAS HAD A FRONT END SHIMMY SINCE IT WAS PURCHASED. UPDATED 4/22/2015 *JS

Sep 09, 2014

CONTINUED INTERMITTENT DRAGGING OF REAR DISK BRAKES. BRAKES HAVE BEEN REPLACED SEVERAL TIMES--DRAGGING CONTINUES TO THIS DATE--8/7/2014. VEHICLE HAS BEEN TAKEN TO FORD DEALER--CAN'T ISOLATE THE PROBLEM. *TR

Aug 07, 2014

FUEL SYSTEM, GASOLINE

4 complaints

STALLS OUT AFTER HOT RUN AND WONT RESTART UNTIL COOLS DOWN AND SOMETIMES AFTER COOL DOWN IT WONT START WITHOUT USING ASTARTER FLUID.STARTS STALLING AROUND 60 MPH.THIS IS A 6.0 DIESEL TRUCK.HAS STOPPED RUNNING RUNNING DOWN THE ROAD AFTER YOU LET OFF GAS PEDAL.HAVE NOTIFIED FORD OF THIS PROBLEM AND FOUND THAT THERE WAS A RECALL ON THIS TRUCK.WAS TOLD THAT THERE IS NOT A RECALL BY FORD WHEN I CALLED THEM. *TT

Sep 17, 2011

THE FUEL INJECTION CONTROL MODULE (FICM) FAILED ON MY TRUCK, CAUSING THE ENGINE TO NOT START OR RUN. THIS IS A VERY COMMON COMPONENT FAILURE FOR THE 6.0L DIESEL ENGINE. IF IT FAILS WHEN THE VEHICLE IS BEING DRIVEN, IT COULD CAUSE LOSS OF CONTROL, LOSS OF POWER STEERING, LOSS OF BRAKING CAPABILITY. FORD MUST BE AWARE OF THE COMMON FAILURE OF THIS COMPONENT, YET NO RECALL TO REPLACE THESE FAULTY MODULES HAS BEEN ISSUED. IN THE INTEREST OF PUBLIC SAFETY, I REQUEST THAT FORD BE REQUIRED TO REPLACE ALL EXISTING FICM'S ON THE 6.0L DIESEL ENGINE WITH ONE OF BETTER QUALITY, AND REIMBURSE ALL OWNERS OF THESE VEHICLES THAT HAVE ALREADY PAID THE EXCESSIVE REPAIR COSTS, COMMONLY OVER $1000, TO HAVE THEIR FAILED FICM'S REPLACED.

Apr 20, 2011

TL*THE CONTACT OWNS A 2005 FORD F-250 SUPER DUTY. WHILE DRIVING AT APPROXIMATELY 10 MPH, THE VEHICLE STALLED; HOWEVER, IT CONTINUED TO MOVE FORWARD UNTIL IT CRASHED. A POLICE REPORT WAS NOT FILED. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS TOLD THAT THE FUEL INJECTOR CONTROL MODULE NEEDED TO BE REPLACED. THE MANUFACTURER WAS ALSO NOTIFIED AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 05V266000 (FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 53,568 AND THE CURRENT MILEAGE WAS 54,568.

Feb 15, 2011

Crash: 1

TL*THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING 65 MPH, THE VEHICLE MISFIRED WITHOUT WARNING AND SHUT OFF APPROXIMATELY TEN SECONDS LATER. THE CONTACT WAS ABLE TO COAST THE VEHICLE OFF THE ROAD AND, APPROXIMATELY 15 MINUTES LATER, THE VEHICLE WAS ABLE TO BE RESTARTED. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THE FUEL INJECTORS FAILED. THE VIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 156,000 AND FAILURE MILEAGE WAS 135,000.

Sep 04, 2007

ELECTRICAL SYSTEM

3 complaints

Odometer Fraud. The contact owns a 2005 Ford F-250. The contact purchased the vehicle from a private seller on social media. The contact stated that the sellers advertisement indicated the odometer mileage was 96,000. The contact later purchased a new vehicle and decided to sell the existing vehicle. The existing vehicle was posted on social media for sale. A potential buyer noticed the vehicle and obtained a Carfax report. The potential buyer then sent a copy of the Carfax report to the contact. The Carfax report indicated that the odometer was reported at 303,000 in 2023. The contact then contacted the seller and informed the seller of the discrepancy. The contact was informed that the odometer had been swapped prior to the sale. The contact stated that seller then deleted the advertisement from social media and rejected all further communications with the contact.

Oct 09, 2025

TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE, BUT THE FAILURE PERSISTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 113,000.

Nov 05, 2015

TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE RESTARTED AFTER MULTIPLE ATTEMPTS; HOWEVER, THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE ICP PRESSURE SYSTEM FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

Jan 08, 2015

TIRES

3 complaints

The tire is a Cooper (Discoverer/Rigged Trek) 35x12.50R20LT. The tire is unreadable as it ripped off the bead. While driving, a sudden pop suddenly occurred and smoke began to appear. I pulled over and realized the entire tire popped/blew up. No accident, it was at 35mph approximately. The vehicle has not been inspected yet as I am typing this while waiting for a tow truck.

Sep 09, 2023

SO FAR 3 OF 4 TIRES HAVE LOST THEIR SHAPE BY BELT SEPARATION. THEY ALL WENT AROUND 25 THOUSAND MILES.

Nov 23, 2015

TIRE TREAD SEPARATION AND SUBSEQUENT BLOWOUT WHILE TOWING A TRAILER. SECOND TIME IN SIX WEEKS WITH THIS TYPE TIRE/MILEAGE. *KB

Jul 05, 2011

STEERING,SUSPENSION,WHEELS

3 complaints

In 2014, I got the “Ford death wobble” in the right front. VERY scary and dangerous. Trying to quickly slow down to stop it in traffic is almost as dangerous as the wobble itself. You have very little to no control with the steering when it happens. I had to repair the problem out of pocket because Ford won’t do anything about it. Now, two weeks ago, I had the same death wobble happen at 70 mph on the left front. So frightening. My passengers thought we had a blowout and we’re about to crash. I successfully slowed it down but this problem is a road hazard to me and everyone else on the road. So now, once again, it’s on me to shell out to fix a problem that should have been a recall a long time ago but Ford won’t step up and do the right thing. Please give us some relief here.

Oct 02, 2022

2005 FORD F250 WITH APPROXIMATELY 19,100 MILES. ORIGINAL FACTORY TIRES, SUSPENSION- NO MODIFICATIONS. TIRE PRESSURE SET TO FACTORY DOOR LABEL SPECS. ON MONDAY, 8-19-2019 WHILE ON I-95, TRAVEL SPEED AT ABOUT 60 M.P.H., I DROVE OVER A BRIDGE EXPANSION JOINT & THE ENTIRE TRUCK STARTED SHAKING VIOLENTLY. STEERING WHEEL WAS VIBRATING/SHAKING MAKING IT DIFFICULT FOR ME TO MAINTAIN CONTROL OF THE TRUCK IN MY ESTABLISHED LANE AND NEARLY TOOK OUT SEVERAL CARS IN THE ADJACENT LANES NEARLY CAUSING MULTI-VEHICLE COLLISION. WENT ON THE INTERNET & FOUND THOUSANDS OF SIMILAR COMPLAINTS REGARDING THIS SAME ISSUE I JUST EXPERIENCED. LATER FOUND OUT IT IS CALLED HARMONIC RESONANCE A.K.A. THE DEATH WOBBLE. THIS DANGEROUS SITUATION AFFECTS NOT ONLY THE DRIVER AND THE PASSENGERS IN THE DEFECTIVE VEHICLE, BUT TO OTHER UNSUSPECTING MOTORIST'S AND THEIR PASSENGERS WHOM SHARE THE SAME ROADWAYS.

Aug 26, 2019

I WAS ON THE INTERSTATE DRIVING 70 MPH WHEN I HIT A SMALL BUMP IN THE ROAD WHICH CAUSED MY TRUCK TO SHAKE VIOLENTLY AND LOSE CONTROL OF STEERING WHICH TOOK ME OFF THE ROAD INTO THE CENTER MEDIAN. THIS COULD HAVE EASILY BEEN A HEAD ON COLLISION IN DIFFERENT CIRCUMSTANCES. *TR

Mar 16, 2012

UNKNOWN OR OTHER

3 complaints

Death wobbles at random

Dec 28, 2021

IN THE MIDDLE OF THE NIGHT, THE HORN STARTED GOING OFF AND AND WOULDN'T STOP UNTIL THE BATTERIES WERE DISCONNECTED. TOOK TO THE DEALERSHIP, BUT THEY COULDN'T REENACT THE PROBLEM. THEY SAID THAT THE AIR BAG EXPANDS AND CAN PUSH ON THE HORN. THE ONLY WAY TO FIX IS REMOVE THE AIR BAG WHICH IS BEHIND THE HORN TO FIX WHATEVER THE PROBLEM IS. WE WERE TOLD THAT WE WOULD HAVE TO PAY FOR THAT. I THINK THIS IS A FORD ISSUE AND A HORN IS A SAFETY ISSUE AND A VERY MUCH NEEDED PART OF A VEHICLE. SO THEY TOOK THE FUSE OUT OF THE HORN SO THE HORN WOULDN'T BLARE IN THE MIDDLE OF THE NIGHT. TRIED PUTTING THE FUSE BACK IN WHEN THE TEMPERATURE ISN'T COLD, BUT THE HORN IMMEDIATELY STARTS TO BLARE AND WON'T STOP. THEREFORE, THE TRUCK HAS NO HORN. THIS IS A BIG SAFETY ISSUE.

Apr 15, 2021

CRUISE CONTROL WOULD NOT DISENGAGE. WHEN MY HUSBAND PRESSED THE BRAKES, THE CAR SPED UP. WE HAD TO PASS 5 VEHICLES, BARELY ENOUGH ROOM. HE FINALLY TURNED THE MOTOR OFF AND WAS ABLE TO PULL OFF THE FREEWAY (I70). BUT FOR THE GRACE NOT GOD, WE WOULD HAVE DIED OF INJURED OURSELVES AND OTHERS. BRAKES SHOULD NEVER MAKE YOUR CAR SPEED UP.

Jul 14, 2020

ELECTRICAL SYSTEM,ENGINE

3 complaints

The contact owns a 2005 Ford F-250. The contact stated while driving at various speeds, the vehicle loss motive power. The vehicle was later restarted and the vehicle operated as designed. The vehicle was taken to the local dealer who replaced the fuel injection control module however, the failure recurred. The manufacturer was notified of the failure and the contact was informed that the vehicle was not included in NHTSA campaign number 05V270000 (Electrical System). The contact indicated that the vehicle had experienced the same failure listed in the recall. The failure mileage was 36,000.

May 24, 2021

WHEN DRIVING, THE TRUCK WILL DIE. SOMETIMES TRUCK CAN BE RESTARTED OTHER TIMES HAD TO HAVE IT TOLLED. WE HAVE REPLACED FUEL PRESSURE REGULATOR, REGULATOR, START SWITCH R&R INSTRUMENT CLUSTER, ALTERNATOR, BATTERIES AND THE PROBLEM STILL EXIST. HAVE TAKEN IT TO A FORD DEALER AND THEY CAN NOT FIND THE PROBLEM. THEY SAY IT IS NOT COVERED ON RECALL 05V270000

Feb 19, 2021

TL* THE CONTACT OWNS A 2005 FORD F250. THE CONTACT STATED THAT THE VEHICLE WAS HESITANT UPON START-UP. THE FAILURE WAS RECURRING. THE STARTER WOULD TURN OVER BUT THE ENGINE WOULD NOT ENGAGE. THE BATTERY WAS REPLACED TWICE BUT TO NO AVAIL. ADDITIONALLY, BLACK SMOKE WAS EMITTING FROM THE VEHICLE AND THE VEHICLE WOULD STALL SPORADICALLY. THE VEHICLE WAS TO BE INSPECTED, DIAGNOSED AND REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 109000.

Apr 17, 2014

Fire: 1

FUEL/PROPULSION SYSTEM

3 complaints

WHEN TRYING TO PUMP FUEL AT A GAS STATION GAS WILL SPIT BACK OUT, ALOT. TAKES 15 MINS TO PUMP 2 GALLONS. TRUCK IS PARKED AND NOT RUNNING.

Mar 17, 2019

TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT THE SAFETY STRAPS THAT SECURED THE FUEL TANK WERE RUSTED AND FRACTURED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.

Jun 01, 2015

THE 2005 FORD F250 PICKUP TRUCKS HAS AN ISSUE WHILE FILLING VEHICLE WITH FUEL. THE FUEL SHOOTS OUT OF GAS TANK FILL INLET DURING THE FUELING PROCESS. THIS PROBLEM WILL HAPPEN WITH THE FUEL GAUGE REGISTERING EMPTY, HALF, OR NEAR FULL. I HAVE HAD GAS SHOOT ALL OVER ME AND OTHER PEOPLE TIME AND TIME AGAIN. I HAVE BEEN INSTRUCTED TO NOT GET GAS IN THAT TRUCK AT EVERY GAS STATION NEAR MY HOME. I HAVE TO DRIVE ACROSS TOWN TO GET GAS. AS SOON AS THEY NOTICE FUEL SPILLING OUT OF MY TRUCK, I WILL BE BANNED FROM THEIR STATIONS TOO. THERE ARE 8 GAS STATIONS WITHIN 5 BLOCKS THAT HAVE BANNED ME. IT COSTS ME APPROX. $4 TO GO GET FUEL, EVEN THOUGH THERE IS A STATION 1 BLOCK AWAY. I CONTACTED FORD CUSTOMER SERVICE MANY TIMES. THEY CLAIM IT ISN'T A RECALL ISSUE. I RESEARCHED THE FORD EXECUTIVES COMPANY EMAIL ADDRESSES AND SENT EMAILS TO THEM. THE EMAIL ADDRESSES WERE STILL VALID AND NOT RETURNED. THE EMAILS MADE IT TO THOSE EXECUTIVES BUT THEY NEVER RESPONDED. I EXPLAINED THAT THE FUEL SPILLAGE IS CAUSING A HUGE SAFETY CONCERN AND MAY KILL ME OR SOMEONE ELSE. I EXPLAINED THAT THE PROBLEM MAY CAUSE AN EXPLOSION AT A STORE. THE FORD MOTOR SERVICE PROFESSIONALS HAVE TOLD ME THAT THE FILTER IN THE TANK HAS GONE BAD. I HAVE MADE THE COSTLY REPAIR 4 TIMES SINCE MAY OF 2008. IT WORKS WELL FOR A FEW MONTHS AND THEN THE GAS SHOOTS OUT AGAIN. ON ONE OF THOSE INSTANCES, THE FUEL SPILLED OUT, AND I FINISHED FUELING AND PULLED TO THE FRONT OF THE STORE TO REPORT THE SPILLAGE. SOMEONE DROVE UP IN THAT SPOT SMOKING A CIGARETTE AND CAUSED A FIRE FROM THE FUEL SPILLED AT THE PUMP. I WAS BANNED FROM THAT STORE AS WELL. I HAVE TO EITHER PAY FOR A COSTLY GAS TANK FUEL FILTER REPLACEMENT, GET BANNED FROM STORES FOR HONESTLY REPORTING THE SPILLAGE, OR FUEL UP AND DRIVE AWAY FROM THE STORE BEFORE SOMEONE NOTICES THAT I SPILLED FUEL. I DON'T LIKE DOING ANY OF THOSE THINGS. FORD DOESN'T CARE. *TR

Aug 21, 2014

Fire: 1

Injuries: 1

WHEELS

3 complaints

THE WHEELS ON MY TRUCK ARE CRACKING AND BREAKING. THEY ARE 20X8 INCH FORGED ALUMINUM FACTORY INSTALLED OEM EQUIPMENT. THIS IS THE SECOND WHEEL I HAVE HAD TO REPLACE AT A VERY EXPENSIVE COST. THE FIRST ONE I THOUGHT MAY HAVE BEEN A FLUKE AS MY TRUCK HAS NEVER BEEN IMPACTED AT THE TIRE OR WHEEL AREAS.I HAVE DONE A LITTLE RESEARCH AND I HAVE FOUND MANY COMPLAINTS FROM MANY TRUCK OWNERS. THIS IS A VERY SERIOUS AND DANGEROUS ISSUE.I HAVE BEEN INVOLVED IN THE AUTOMOTIVE INDUSTRY FOR MANY YEARS AND I HAVE NOT SEEN ANYTHING LIKE THIS ISSUE. THIS ISUUE CAN AND WILL HAPPEN WHILE VEHICLE IS PARKED OR MOVING, MORE PROBABLE WHILE IN MOTION. THE FIRST TIME THIS HAPPENED THE TRUCK HAD 80000 MILES ON IT.

Sep 23, 2017

PURCHASED BF GOODRICH TIRES FROM DISCOUNT TIRE 2 YEARS AGO, WITH 21000 MILES ON THE TIRES ONE TIRE HAD TREAD SEPARATION WHICH WAS REPLACED WITHOUT INCIDENT IN AUGUST 2015. IN OCTOBER 2015, WHILE TRAVELING AT APPROXIMATELY 50 MPH DOWN HILL ON I-17 FROM SUNSET POINT THE DRIVER'S SIDE REAR TIRE TREAD SEPARATED CAUSING A NEAR ACCIDENT. THE TIRE CAUSED MINOR DAMAGE TO THE WHEEL WELL AND HAD TO OBVIOUSLY BE CHANGED. TIRE WAS REPLACED BY DISCOUNT. PROBLEM LIES IN THE FACT THAT WE BOUGHT FOUR TIRES ALL FROM THE SAME STOCK. WE ANTICIPATE SIMILAR PROBLEMS WITH THE REMAINING TWO BUT ARE NOT WILLING TO RISK OUR LIVES TO FIND OUT WHEN THEY WILL SEPARATE AND GO FLAT ON US. WE ARE NOW FORCED TO BUY TWO NEW TIRES AT FULL VALUE OUT OF FEAR OF THE UNKNOWN AS WE TRANSPORT OUR GRANDCHILDREN OFTEN AND HAVE PLANS TO TAKE OUR TRAVEL TRAILER OUT. THE BF GOODRICH TIRES ARE 275/65 R20 (BEOT UH11 0212).

Oct 29, 2015

TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, THE CONTACT DISCOVERED CRACKS ON BOTH THE FRONT PASSENGER AND REAR DRIVER'S SIDE WHEELS. THE VEHICLE WAS TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 90,000.

Jun 04, 2012

SERVICE BRAKES, HYDRAULIC

3 complaints

TL* THE CONTACT OWNS A 2005 FORD F250. THE CONTACT WAS DRIVING 70 MPH AND AS HE APPLIED THE BRAKES, THE PISTON ON THE CALIBER LOCKED ABNORMALLY. THE CONTACT STATED THAT THE FAILURE WOULD OCCUR INTERMITTENTLY. THE VEHICLE HAD BEEN TO THE DEALER THREE TIMES FOR REPAIRS YET THE FAILURE CONTINUED TO RECUR. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS 15,000 AND THE CURRENT MILEAGE WAS 87,000.

Sep 17, 2010

2005 FORD F250. PROBLEM WITH THE BRAKE BOOSTER*CW THE CONSUMER STATED HE HAS THE SAME PROBLEM AS THE F150'S THAT ARE BEING RECALLED, BUT FORD ADVISED HIM HIS MODEL WAS NOT BEING RECALLED.

Apr 21, 2010

SDHSDFH. *TR

Feb 19, 2008

STRUCTURE

2 complaints

TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT HEARD A RATTLING SOUND UNDERNEATH THE VEHICLE WHILE DRIVING. THE CONTACT LOOKED UNDERNEATH THE VEHICLE AND NOTICED THAT THE BRACKETS TO THE VEHICLE WERE RUSTED AND PARTIALLY DETACHED. THE CONTACT NOTICED THAT THE FRAME UNDERNEATH THE VEHICLE, WHICH ATTACHED THE BED TO THE FRAME AND THE MOTOR TO THE ENGINE, WAS RUSTING. THE CONTACT NOTICED THAT THE BRACKETS WERE BEGINNING TO SEVERELY RUST AND SLIGHTLY DETACH. WHEN THE VEHICLE WAS PARKED, THE CONTACT WOULD SOMETIMES NOTICE PIECES OF THE FRAME ON THE GROUND. THE CONTACT TOOK THE VEHICLE TO THE HENDER FORD AND RAMSEY'S FORD DEALERS WHERE BOTH PLACES CONFIRMED THE RUST FAILURE TO BE AN ISSUE. THE VEHICLE DID NOT RECEIVE OFFICIAL DIAGNOSTIC TESTING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 147,000.

Jun 09, 2017

TRUCK SHAKES WHEN YOU HIT A BUMP AND IT FEELS LIKE RIDING ON FOUR BASKETBALLS BOUNCING AT DIFFERENT TIMES. *TR

Apr 21, 2009

UNKNOWN OR OTHER,ENGINE,FUEL/PROPULSION SYSTEM

2 complaints

WHILE DRIVING MY TRUCK IT HAS STOPPED RUNNING AND JUST SHUT ITSELF OFF LIKE ITS NOT GETTING FUEL. I HAVE READ THE COMPLAINTS ON THE F250 SUPER DUTY AND MY TRUCK IS RESPONDING EXACTLY THE SAME WAY. I AM AFRAID TO DRIVE IT DUE TO SOMEONE HITTING ME OR IT CAUSING AN ACCIDENT SO I LOOKED ON HERE TODAY AND SAW THE RECALL FOR THE SUPER DUTY. THIS IS A SERIOUS AND DANGEROUS ISSUE THAT SOMEONE DEFINITELY NEEDS TO ADDRESS. I WAS DRIVING DOWN THE ROAD AND THE VEHICLE LOST POWER AND I TRIED TO PUSH THE PEDAL TO GET FUEL BUT NOTHING HAPPENED. I AM VERY LUCKY THE VEHICLE BEHIND ME WAS BACK FAR ENOUGH THAT I TURNED ON MY FLASHERS AND THEY NOTICED OR I COULD HAVE CAUSED AN ACCIDENT OR WORSE.

Apr 02, 2016

ENGINE STALLED WITHOUT WARNING DRIVING IN TRAFFIC WHILE WEAVING IN AND OUT OF TRAFFIC TRYING TO AVOID HITTING OTHER VEHICLES OR THEM HITIING ME. A DANGEROUS, INTENSE MOMENT TRYING TO GET MY TRUCK OFF THE ROAD WITH NO POWER STEERING OR POWER BRAKES. THIS TRUCK MAY OR MAY OR M AY NOT START. NO CRANK/NO START, NO START/CRANKS, NO START/BUCKING AND STALLING ENGINE. THESE ISSUES RELATE TO THE INJECTOR WIRING HARNESS DUE TO CHAFFING AND CRUSHING, A VERY TIME CONSUMING TASK. TECHNICIAN VERIFIED THE HARNESS IS WORN AND WIRES ARE EXPOSED. PAST FORD CUSTOMERS REFER TO THE VIOLENT SHAKING THAT WHILE DRIVING THIS TRUCK AS THE "DEATH WOBBLE." AN INTENSE MOMENT.THIS IS A RISK CONCERNING VEHICLE SAFETY. THIS IS NOT PROTECTING CONSUMERS AGAINST UNREASONABLE RISKS OF ACCIDENTS OCCURING. THE TIRES ON MY TRUCK ARE MICHELINS. THEY ARE THE SIZE RECOMMENDED BY FORD FOR THIS VEHICLE. CUSTOMER SERVICE WAS CONTACTED TWICE. BOTH REPLYS WERE THE SAME.THERE ARE NO WARRENTIES, RECALLS OR PROGRAMS IN EFFECT THAT WOULD PROVIDE COVERAGE FOR YOUR CURRENT CONCERN. KEEP RECEIPTS, ETC. FORDS PRESENTATION TO- FORD IDENTIFIED A NUMBER OF POTENTIAL FAILURES MECHANISMS THAT COULD EFFECT ENGINE PERFORMANCE IN THIS VEHICLE POPULATION INCLUDING THE WIRING CONDITIONS ADDRESSED BY NHTSA. 05V-270. THE WIRING CONDITIONS BOTH EFFECT ENGINE FUELING WERE THE ONDITIONS TO RESULT IN ENGINE STALL." VEHICLES AFFECTED WERE BUILT 9-29-2003 5-31-2004 IN LOUISVILLE KY. MINE 8-2004 IN LOUISVILLE. THERE HAVE BEEN NUMERIOUS COMPLAINTS CONCERNING SAFETY WITH THIS POPULATION OF F-SERIES TRUCKS, THEN AND NOW. FORD IS AWARE OF THE FAILURE AND EXPECTS THE CONSUMER TO PAY FOR THE THIER MISTAKE. IF NHTSA HADN'T STEPPED IN WHEN THE DEFECTS WERE DISCOVERD, FORD WOULD HAVE DONE NOTHING. NHTSA STATED FURTHER ACTION WILL BE TAKEN IF WARRENTED BY FUTURE CIRCUMSTANCES. IN THE INTEREST OF PUBLIC SAFETY, THE TIME FOR FURTHER ACTION IS NOW.

Nov 18, 2015

ENGINE AND ENGINE COOLING,POWER TRAIN

2 complaints

TL * THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 65 MPH DOWN AN INCLINE, HE SHIFTED INTO NEUTRAL AND RELEASED THE CLUTCH WHEN THE VEHICLE STALLED. THE CONTACT MENTIONED THAT ALL OF THE WARNING LIGHTS ON THE INSTRUMENT PANEL ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE TO RECTIFY THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 29,000 AND THE CURRENT MILEAGE WAS 31,000. UPDATED 08/12/14*LJ

Jun 05, 2014

REGULAR DRIVING ON OPEN ROAD , NO HARSH CONDITIONS - POWER LOSS, WITHOUT ANY WARNING - NO ENGINE LIGHTS OR WARNNGS - SUDDEN DECELLERATION , JERKY RESPONSE MORE DECELLERATION - LIMP OFF RAMP , LIMP HOME. TURBO SOUNDING WHINY AND DIFFERENT , NO RESPONSE TO ADDED PRESSING ON GAS , NOR STOP , RESTART. HAS BEEN EVALUATED AT DEALERSHIP MANY TIMES AND MANY PROBLEMS CORRECTED, PAID FOR YET NOTHING WORKS - REGULAR MAINTENANCE IS PREFORMED ON THIS VEHICLE , MUCH CARE IS TAKEN BY OWNER. VERY DANGEROUS CONDITION WILL CAUSE A WRECK , CAN NO LONGER ENDANGER LIVES, WE DO EVERYTHING THE DEALERS ASK AND CONDITION RETURNS. MUST EVALUATE AT NEW DEALERSHIP AND WHETHER OR NOT CAN KEEP. I AM GETTING POST TRAUMATIC STRESS FROM THIS VEHICLE AND IT'S LACK OF UNRELIABLE TRANSPORT . I FEAR GETTING INTO THE CAR FOR ANY DISTANCE - IF I HAVE TO RETURN TO THE BANK , I MUST ADVISE THEM NOT TO RE-SELL LIABILITY REASONS AND INFORM THEM OF CHRONIC LEMON PROBLEMS IN THIS MODEL F250 6.0 FORD TRUCK . *TR

Jan 28, 2013

FUEL SYSTEM, DIESEL

2 complaints

WHILE DRIVING DOWN THE HIGHWAY AT 70 MPH, MY 2005 FORD F-250 DIESEL TRUCK ENGINE SUDDENLY DIED. I HAD TO WRESTLE WITH THE TRUCK TO GET IT STOPPED AND PULLED OVER TO THE SIDE OF THE ROAD. I HAD NO STEERING WHEN THE TRUCK ENGINE STALLED SUDDENLY AND HAD TROUBLE GETTING IT STOPPED. I WAS TOWED HOME AS THE TRUCK WOULD NOT RESTART. WE THEN TOWED IT TO THE DEALERSHIP FOR REPAIRS ON JULY 26TH, AND IT HAS BEEN THERE UNTIL TODAY, SATURDAY, AUGUST 7TH, 2010. THE DEALERSHIP REPLACED THE HIGH PRESSURE OIL PUMP AT OVER $1200.00. EVEN THOUGH THE TRUCK HAD 62,000 MILES, IT HAD JUST GONE OVER 5 YEARS OLD. WE WERE TOLD THIS IS A BIG PROBLEM WITH FORD DIESELS AND THE FORD ENGINEERS ARE TELLING CONSUMERS THAT THEY AREN'T CHANGING THE OIL ENOUGH. I CONSISTENTLY CHANGED THE OIL IN THAT TRUCK EVERY 5000 MILES WITH DELO 400 AS I WAS TOLD TO DO. THERE NEEDS TO BE AN INVESTIGATION OF FORDS HIGH PRESSURE PUMPS AND THE AMOUNT OF MONEY CONSUMERS ARE HAVING TO PAY FOR REPAIRS BECAUSE OF THIS DEFECTIVE PART. I ASKED TO HAVE THE HIGH PRESSURE PUMP THAT WAS REMOVED FROM MY TRUCK, AND I WAS TOLD THAT HE HAD TO SEND IT BACK TO FORD BECAUSE IT HAD A VERY EXPENSIVE CORE. I'M SURE THEY DID NOT WANT ME TO HAVE THE EVIDENCE. *TR

Aug 07, 2010

TL*THE CONTACT OWNS A 2005 FORD F-250. THE FUEL TANK ASSEMBLY FAILED AND WAS REPLACED, BUT THE FAILURE RECURRED. THE FAILURE TYPICALLY OCCURS WHEN THE WARRANTY HAS EXPIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGES WERE 60,000.

Mar 05, 2008

POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

1 complaint

Electrical system fails every day. It affects the engine, transmission, radio, windows, gauges. Wiring issue causes the radio to just go out, windows stop working, all gauges stops working, the transmission doesn't shift right, engine doesn't run right. Yes vehicle is available for inspecting. Engine cuts off and won't start back, leaves you stranded side the road. Truck stalls in front of other vehicles. Windows won't roll down when it's 100 degrees inside truck. Fuel gauge doesn't let you know when there's no fuel again leaving you stranded beside the road. Other gauge don't work could cause more damage. Yes it has been inspected my mechanic and he said there are wiring issues. No warning lamps or anything now but the wrench light has came on allot. There is a wiring recall on this year truck but said mine doesn't fall under that recall and I don't know why because I'm having this issue

Apr 06, 2025

STEERING,POWER TRAIN,ELECTRICAL SYSTEM

1 complaint

Wrench light comes on, but truck goes into limp loses power very dangerous don't know if it's going to cause me to be rear-ended, steering goes back and forth right to left can't hardly hold it in road

Aug 05, 2024

STEERING,ELECTRICAL SYSTEM,STRUCTURE

1 complaint

The back bed rails rot/rust very quickly and trying to buy new beds run 4500$ along with o2 sensors ir intake sensors go out of blue no reasoning let alone the power steering lines rusting very very quickly

Apr 10, 2024

UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM

1 complaint

VEHICLE RANDOMLY DIES WHILE DRIVING DOWN ROAD DOES NOT MATTER SPEED OR WHAT ROAD YOU ARE ON HAPPENS TO THE POINT WE ALMOST EXPECT IT NOW EVERYTIME WE DRIVE. IT WILL ACT FINE NO WARNING THEN IN MIDDLE OF DRIVING IT JUST SHUTS OFF VERY DANGEROUS. IT ALSO, WILL RANDOMLY LOSS POWER NOT ALL THE TIME BUT OCCASIONALLY IF GOING OVER 45MPH, THE A/C WORKS UNTIL YOU DRIVE OVER 45MPH THEN JUST STOPS UNTIL YOU GET TO A STOP SIGN. TAKE OFF AGAIN ITS FINE TIL THAT 45MPH MARK THEN BLOWS HOT. HAD TRUCK SINCE SEPT. 2018 & HAVE HAD THE PROBLEM SINCE AT LEAST 1 OUT OF 4X DRIVING THIS WILL ALL HAPPEN. TRUCK ALSO HAS PROBLEMS WITH FUELING UP THE TANK IT SHUTS THE PUMP OFF CONSTANTLY. MAIN PROBLEM & MOST WORRISOME IS THE SHUTTING OFF RANDOMLY WHILE DRIVING.

Oct 26, 2019

STEERING,SUSPENSION,SERVICE BRAKES, HYDRAULIC

1 complaint

TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SUDDENLY VIBRATED AND PULLED TO THE LEFT. WHILE INSPECTING THE VEHICLE, THE CONTACT DISCOVERED THAT THE BRAKE CALIPERS WERE HOT TO THE TOUCH. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE LOCAL DEALER WAS NOT NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS CONTACTED. THE FAILURE MILEAGE WAS 109,000.

Mar 27, 2019

STEERING,FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM,SERVICE BRAKES

1 complaint

TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING 70 MPH, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOORBOARD. THE CONTACT STATED THAT THE BRAKE PEDAL HAD TO BE PUMPED SEVERAL TIMES AND THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. ADDITIONALLY, THE VEHICLE STALLED WITHOUT ANY WARNING INDICATORS ILLUMINATING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BATTERY, ALTERNATOR, AND FUEL INJECTION CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE LOCAL DEALER WAS NOT CONTACTED FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 162,000.

May 21, 2018

STRUCTURE,UNKNOWN OR OTHER,ENGINE

1 complaint

TRUCK FRAME SEEMS TO BE ROTTING. TOLD 3-4 YEARS AT MOST BY MECHANIC. ALREADY REPLACES FUEL TANK BRACKETS, ANY RUST RECALLS AS IN ONES TOYOTA DID A WHILE AGO/ ALSO TOLD AT 1000,000 MI WILL NEED SPARK PLUG CHANGE (ONLY59000 NOW) AND THERE WAS A RECALL OF THIS PLUG REMOVAL COULD BE DIFFICULT. ANY HELP

Oct 21, 2017

STEERING,SUSPENSION,UNKNOWN OR OTHER

1 complaint

AT ANYWHERE BETWEEN 45MPH, AND 70 THE TRUCK WILL WOBBLE AND SHAKE OUT OF CONTROL TO THE POINT WHERE YOU CAN ALMOST LOOSE CONTROL. TRUCK CAN BARELY BE DRIVEN AND IS VERY UNSAFE

Oct 04, 2017

ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL INJECTOR CONTROL MODULE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE FUEL INJECTOR WAS REPLACED AGAIN. IN ADDITION, THE VEHICLE EXPERIENCED EXCESSIVE COOLANT CONSUMPTION AND OPERATED ABNORMALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE EGR VALVE AND OIL COOLER FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000.

May 05, 2016

FUEL SYSTEM, DIESEL,ELECTRICAL SYSTEM

1 complaint

TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE FAILED TO OPERATE AND STALLED. THE VEHICLE WAS ABLE TO RESTART. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL INJECTION CONTROL MODULE AND INJECTION CONTROL PRESSURE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V27000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,100. UPDATED 06/21/16*LJ

Apr 06, 2016

STRUCTURE,SERVICE BRAKES

1 complaint

TL* THE CONTACT OWNS A 2005 FORD F250. THE CONTACT STATED THAT THE BRAKES WOULD NOT FULLY ENGAGE WITHOUT ABRUPT FORCE BEING APPLIED AND THE WHEELS WOULD CONTINUE TO ROLL AS IF THE ACCELERATOR WAS APPLIED. THE VEHICLE HAD BEEN TAKEN TO AN INDEPENDENT MECHANIC FOR ROUTINE SERVICE. ADDITIONALLY, THERE WAS RUST AND CORROSION ON THE BEAMS FOR THE TRUCK BEDDING WHICH EXHIBITED AN ABNORMAL NOISE.THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER:06E087000 (SERVICE BRAKES, AIR). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 5000.

Mar 19, 2014

STEERING,SUSPENSION,SERVICE BRAKES

1 complaint

THIS IS THE FIRST OF FOUR TIMES THAT I HAVE HAD TO HAVE BRAKE WORK DONE ON MY TRUCK. THREE OF THE TIMES I WAS TOLD THAT THE CALIPERS HAD FROZEN AND SO CALIPERS PADS AND (EXCEPT THIS LAST TIME) ROTORS HAD TO BE REPLACED. THIS IS ABSURD FOR A TRUCK WITH LESS THAN 45,000 MILES. UNDERSTAND THIS IS EXPENSIVE!! HAVE NEVER HAD ANYTHING LIKE THIS ON ANY OTHER VEHICLE. ALSO, I HAVE EXPERIENCED THE OFT TALKED ABOUT "DEATH WOBBLE" A FEW TIMES ON THE HIGHWAY. WAS REAR BRAKES IN 2010' FRONTS IN 2011' NOW REARS AGAIN IN 2013. *TR

Mar 18, 2013

POWER TRAIN,ENGINE

1 complaint

WHILE AT A DEAD STOP, PLACED TRUCK IN DRIVE AND THE ENGINE SUDDENLY ACCELERATED TO FULL POWER LUNGING THE VEHICLE FORWARD 10' WHILE I SIMULTANEOUSLY APPLIED BOTH FEET TO THE BRAKE FOR MAXIMUM STOPPING POWER. THIS IS THE THIRD TIME IN TWO TO THREE MONTHS THIS HAS HAPPENED. NO CHECK ENGINE LIGHTS ARE ON. TOOK MY CAR TO THE LOCAL FORD DEALER AND WAS TOLD BY THE SERVICE MANAGER THAT THEY HAVE NEVER HEARD OF THIS PROBLEM BEFORE. RESEARCHED THE INTERNET ONLY TO FIND LOTS OF OTHER SIMILAR COMPLAINTS. ORIGINALLY THOUGHT IT WAS HUMAN ERROR, FLOOR MAT, OR SIMILAR PROBLEM... BUT THIS LAST TIME, I WAS PREPARED BECAUSE OF PREVIOUS INCIDENTS. THIS PROBLEM CAN CAUSE A TERRIBLE ACCIDENT AND MAY EVEN RESULT IN DEATH. *TR

Oct 25, 2012

ENGINE AND ENGINE COOLING,STRUCTURE

1 complaint

FRAME IS RUSTING, HEADERS ARE LEAKING FROM RUST. *TR

Oct 03, 2011

ENGINE AND ENGINE COOLING,FUEL SYSTEM, OTHER,ELECTRICAL SYSTEM

1 complaint

2005 FORD F-250. CONSUMER STATES ENGINE FAILURE *TGW THE CONSUMER STATED THE ENGINE FAILURE NEARLY CAUSED AN ACCIDENT, WHEN IT SHUT DOWN ON A MAJOR HIGHWAY. SUBSEQUENTLY, THE CONSUMER ALSO EXPERIENCED A FAILURE WITH THE FUEL INJECTION CONTROL MODULE. AFTER HAVING THE FUEL INJECTION CONTROL MODULE REPLACED, THE CHECK ENGINE LIGHT ILLUMINATED AFTER LEAVING THE DEALERSHIP. THE CHECK ENGINE LIGHT ILLUMINATED DUE TO A FAILED EGR VALVE. THE CONSUMER WAS ALSO INFORMED THE ALTERNATOR WAS SPIKING, AND NEEDED TO BE REPLACED AS WELL AS THE EGR COOLER AND HEAD GASKETS. *JB

Jun 23, 2010

FUEL SYSTEM, DIESEL,POWER TRAIN,ELECTRICAL SYSTEM,TIRES,UNKNOWN OR OTHER

1 complaint

MY 2005 FORD F-250 SUPERDUTY 6.0L DIESEL, FIRST INCIDENT WAS MAY OF 2007, AT 16,000 MILES MY TURBO CHARGER WENT BAD WHEN I WAS TRAILERING MY HORSES IN VERMONT, FORCED TO STOP AT UNKNOWN DEALERSHIP WHO "CLEANED" SOMETHING SO I WOULD MAKE IT BACK TO MY HOME. AGAIN ON THE DRIVE HOME I LOST THE TURBO. IT HAD TO BE REPLACED AT THE DEALERSHIP, COLUMBIA FORD, CT THE NEXT DAY. I WAS TOLD I HAD TO DRIVE MY TRUCK HARD AND EVERYDAY IN ORDER TO PREVENT THE PROBLEM FROM OCCURRING AGAIN. IN MARCH 2010 BROUGHT MY TRUCK TO MONACO FORD, THE MOTOR HAD TO BE REMOVED DUE TO "ALL OF THE GASKETS AND SEALS IN THE MOTOR LEAKING, AS WELL AS THE TURBO CHARGER BEING BAD AGAIN. THIS OCCURRED AT 24,500 MILES. THE SIDE WALLS OF MY TIRES ARE PEELING, THE RUNNING BOARD ON THE DRIVERS SIDE IS FALLING OFF, AND THE BODY SIDE MOLDING IS COMING OFF AND NOW AT 26,000 MILES THE AIR POSITION SELECTOR FOR THE CLIMATE CONTROL SYSTEM IS NOT WORKING. IF I PUT IT IN A POSITION FOR VENTING OR FOR FRONT AND FLOOR I JUST BLOWS THROUGH THE DEFROST VENTS. OBVIOUSLY THE WARRANTY HAS PASSED WITH THE EXCEPTION OF THE MOTOR AND I HAVE 26,500 MILES ON THIS TRUCK. *TR

Jun 22, 2010

FUEL SYSTEM, DIESEL,VEHICLE SPEED CONTROL

1 complaint

MY 2005 FORD F-250 6.0L DIESEL LOST ACCELERATION ONTO A HIGHWAY. IT STALLED AND STARTED BILLOWING WHITE SMOKE FROM THE EXHAUST. AFTER A FEW MOMENTS IT SLOWLY ACCELERATED, BUT NEARLY CAUSED AN ACCIDENT AS CARS RAN UP ONTO US. THE ENGINE WAS MISSING AND WE MADE IT TO AN INTERSECTION TO PULL OFF OF HIGHWAY. WE STOPPED AND RESTARTED THE ENGINE AND IT STARTED RUNNING NORMALLY. HOWEVER, IT HAPPENED AGAIN ONCE WE WERE ON THE ROAD. WE MADE IT TO THE DEALERSHIP WHERE THEY DIAGNOSED THE PROBLEM AS A FAILED "FICM FUEL INJECTOR CONTROL MODULE." THIS HAS BEEN REPORTED TO THEM MULTIPLE TIMES, BUT A RECALL HAS NOT BEEN ISSUED FOR THIS MODEL. I DID FIND REFERENCE TO A RECALL (FORD RECALL NO. 05S34) OF THE EXACT NATURE ON A DIFFERENT YEAR MODEL. I CALLED FORD AND THEY WOULD NOT REIMBURSE THE COST OF THE PART AND LABOR OF $1100. *TR

May 10, 2010

POWER TRAIN,EQUIPMENT

1 complaint

A SNAP RING INSIDE THE TRANSMISSION FAILS ALLOWING THE PLANET TO SHIFT FORWARD BREAKING HOUSING TABS OFF CAUSING A EXTERNAL LEAK OF TRANSMISSION FLUID TO OTHER VEHICLES DRIVING DOWN THE ROAD,NO WARNING A TRANSMISSION MAY LOCK UP CAUSING SAFETY CONCERNS, FORD HAS RECOGNIZED THE SITUATION BEFORE AND SENT A INTERNAL NOTICE TO MECHANICS TO FIX THE PROBLEM, NO RECALL WAS EVER SENT. TRUCKS BETWEEN 90,000 AND 120,000 HAVE THIS PROBLEM, FORD SAID I WAS FIRST EVER COMPLAINT, WHICH IS A LIE, I HAVE FOUND THROUGH RESEARCH EARLY 2004 THROUGH 2006 MODELS HAVE THIS PROBLEM OF FAILURE WITHOUT NOTICE. FORD HOPES FOR THESE TO GET PAST WARRANTY SO CUSTOMER HAS TO PAY A OUTRAGEOUS SUM TO FIX, SO FAR I HAVE FOUND 40 CASES RESULTING THIS SITUATION IN MY AREA ALONE AND MAINLY 9/10 ARE FORD F250S. I SEEN THE INTERNAL COMMUNICATION BUT WAS DENIED A COPY OF IT. MY SERVICE ADVISOR AT SILSBEE FORD SHOWED ME. ALSO THIS PART IS NOT COVERED UNDER ANY EXTENDED WARRANTY, AND FORD DENIES EVER HAVING THIS PROBLEM, THE VEHICLE BEHIND ME WAS SHOWERED WITH TRANSMISSION FLUID ALMOST RESULTING IN A CRASH BECAUSE IT SMEARED ON HER WINDSHIELD TO THE POINT THAT SHE COULD NOT SEE. NO WARNING ,SO SOUND, I DROVE ANOTHER 20 MILES BEFORE I NOTICED A MAJOR SLIP IN SHIFTING AND DISCOVERED A LEAK. THE TRANNY FLUID SPRAYED ALL OVER THE EXHAUST PIPE SMOKING AND A STENCH OF BURNING TRANNY FLUID. *TR

Aug 02, 2009

EQUIPMENT

1 complaint

TL*THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT PURCHASED THE VEHICLE IN JANUARY OF 2005. SIX MONTHS LATER, WHILE DRIVING APPROXIMATELY 45 MPH, SHE HEARD A LOUD POPPING NOISE AND THE AIR CONDITIONER STOPPED WORKING PROPERLY. THE AIR BEGAN COMING FROM THE DEFROST VENTS, BUT IT WAS NO LONGER COOL AIR. THE DEALER AND MECHANIC STATED THAT THE VACUUM PUMP WAS DEFECTIVE. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED AND HAS PERSISTED FOR THE LAST THREE AND A HALF YEARS. ON SIX OCCASIONS, THE DEALER AND MECHANIC STATED THAT THE FAILURE WAS DUE TO THE VACUUM PUMP. A COUPLE OF YEARS LATER, SHE NOTICED TWICE THAT THE AIR CONDITIONING WOULD OPERATE NORMALLY WHEN THE HEADLIGHTS WERE TURNED ON AND OFF. THE MANUFACTURER WAS NOTIFIED AND A COMPLAINT WAS FILED. THE CURRENT MILEAGE WAS 101,388 AND FAILURE MILEAGE WAS 20,000.

Jan 26, 2009

STEERING,TIRES

1 complaint

TL*THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING 55 MPH, THE FRONT END OF THE VEHICLE BEGAN TO SHAKE. THE CONTACT SLOWED THE VEHICLE DOWN AND THE TIRES BLEW OUT. THE VEHICLE VEERED TO THE LEFT AND INTO ONCOMING TRAFFIC. THE CONTACT CRASHED INTO A MOUNTAIN AND THE VEHICLE ROLLED OVER TWICE. THERE WERE NO INJURIES. A POLICE REPORT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE 65,197.

Aug 29, 2008

Crash: 1

FUEL SYSTEM, OTHER

1 complaint

2005 FORD F250 WITH A DEFECTIVE FUEL GAUGE. CONSUMER STATES THAT THE FUEL GAUGE HAS FAILED BEFORE. CONSUMER HAS HAD IT FIXED FOR THE THIRD TIME. DEALER SAID THEY WOULD REPAIR IT AGAIN UNDER WARRANTY. HE IS AFRAID THIS WILL BE AN ONGOING PROBLEM. *KB

Mar 19, 2008

STEERING,STRUCTURE

1 complaint

IN DRIVING MY FORD F-250 PICK-UP, I HAVE EXPERIENCES SEVERE VIBRATIONS/OSCILLATIONS AT HIGH (OVER 60MPH) SPEEDS. THIS OCCURS WHEN THE TRUCK RUNS OVER A SMALL IMPERFECTION IN THE ROAD. THESE OSCILLATIONS ARE QUITE SEVERE - FORCING EMERGENCY LEAVE CHANGE/LOSS OF CONTROL. WHEN THE TRUCK SLOWS DOWN TO ABOUT 40, THE OSCILLATIONS CEASE. THIS SHAKING IS SO SEVERE IT HAS DAMAGED THE PAINT ON THE HOOD DUE TO THE HOOD SLOSHING BACK AND FORTH. IT IS DEFINITELY LIFE-THREATENING. THE FORD DEALER IS AT A LOSS, THEY DO NOT KNOW WHAT TO DO. *TR

Feb 26, 2008

4.8/5.0

99 reviews

Where to Find VIN for Problems Check

To check for problems and complaints on your 2005 FORD F-250, you'll need the VIN number. Find your VIN in one of these 4 common locations.

Where to Find VIN Number on 2005 FORD F-250 for Problems Lookup - Dashboard, Door Jamb, Engine Bay, Documents

Understanding VIN Structure for Problem Reports

Each character in your 2005 FORD F-250 17-digit VIN helps identify specific complaints and problems affecting your vehicle model.

2005 FORD F-250 VIN Structure for Complaint Verification - WMI, VDS, Check Digit, Model Year, Plant Code

How to Check 2005 FORD F-250 Problems in 3 Steps

Locate Your VIN

Find the 17-character VIN on your 2005 FORD F-250 dashboard (visible through windshield), door jamb, engine bay, or vehicle documents.

Review by Component

Browse owner-reported complaints organized by vehicle component (engine, transmission, brakes, electrical) to identify common issues and problem patterns for this model year.

Check Safety Issues

Review crash and fire incidents for each component to assess safety concerns. Contact your FORD dealer or report problems to NHTSA at SaferCar.gov.

Frequently Asked Questions

How many problems does the 2005 FORD F-250 have?

The 2005 FORD F-250 currently has 144 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2005 FORD F-250?

The most common problems reported for the 2005 FORD F-250 are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2005 FORD F-250 problem data come from?

All problem and complaint data for the 2005 FORD F-250 comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.

How do I report problems with my 2005 FORD F-250?

You can report safety problems with your 2005 FORD F-250 directly to NHTSA at SaferCar.gov or call 1-888-327-4236. Your complaint helps identify patterns and may lead to recalls or investigations.

Where can I find my VIN to check problems?

Your 2005 FORD F-250 VIN is located in 4 places: (1) Dashboard near windshield on driver's side, (2) Driver's door jamb sticker, (3) Engine bay, (4) Vehicle registration and insurance documents.

Is the 2005 FORD F-250 reliable?

Reliability can be assessed by reviewing the number and severity of owner complaints for the 2005 FORD F-250. Check complaints by component, crash reports, and fire incidents above to evaluate potential issues and problem patterns.