2006 FORD Five Hundred Problems & Complaints
Real owner complaints and problems reported to the National Highway Traffic Safety Administration (NHTSA). View common issues by component.
364
Complaints Reported
Complaints by Component
VEHICLE SPEED CONTROL
71 complaints
TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. WHILE DRIVING 55-60 MPH, THE ACCELERATOR PEDAL WAS APPLIED AND THE VEHICLE JERKED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO THREE INDEPENDENT MECHANICS WHO STATED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 103,000. THE VIN WAS NOT AVAILABLE.
Nov 06, 2018
I PURCHASED MY CAR 7/31/2012 WITH 113,000 MILES. I RECEIVED NOTIFICATION OF A RECALL FOR THE RPM SURGE IN 2013. CONCERNED, I TOOK MY CAR TO THE DEALERSHIP AND WAS TOLD SINCE I DIDN'T HAVE ANY PROBLEMS AND HADN'T REACHED THE 150,000 MILE LIMIT, THEN I DIDNT NEED TO WORRY ABOUT REPAIRS FOR THE TIME BEING. I THEN ASKED WHAT WOULD HAPPEN IF I SURPASSED THE MILE LIMIT AND THE PROBLEM SURFACED. THE MECHANIC INFORMED ME THAT AS LONG AS A RECALL EVER EXISTED, THEN FORD WOULD ALWAYS BE RESPONSIBLE FOR THE REPAIRS. NOT SATISFIED WITH THAT RESPONSE, (BECAUSE THERE WOULD NOT BE A 10 YR /150,000 LIMIT IN THE LETTER) I QUESTIONED THE MANAGER WHO CONFIRMED THE TECH'S ANSWER. IN 2014 I RELOCATED TO LANCASTER CA. I TOO HAVE HAD NUMEROUS DANGEROUS CLOSE CALLS WITH THE SUDDEN ACCELERATION WHILE BREAKING; ONE BEING IN A SCHOOL PARKING LOT IN HIGH TEMPERATURES. I TOOK MY CAR TO THE DEALERSHIP 5/2016 AND JUST AS EXPECTED, THEY WONT REPAIR MY CAR WITHOUT COST. THIS IS WRONG AND VERY DANGEROUS AND HOPEFULLY YOU GUYS WILL DECIDE TO DO SOMETHING ABOUT THIS FOR THE MANY PEOPLE STILL EXPERIENCING PROBLEMS.
Jul 02, 2016
I WAS TRAVELING NORTH TOWARD ANN STREET IN MONTGOMERY WHEN ALL OF A SUDDEN MY CAR CAME TO AN ABRUPT STOP IN THE MIDDLE OF SPEEDING TRAFFIC AND MY KIDS AND I WERE IN THE MIDDLE OF THE HIGHWAY STRANDED TO GET OUT OF THE CAR WAS THE HARDEST PART NOW I HAD TO GET SOME HELP WHEN I DID THE MAN THAT PULLED MY CAR TO HIS SHOP TOLD ME IT WAS MY THROTTLE CONTROL SENSOR MY WWWWWHHHHAAAT AND I ONLY HAD THE CAR FOR A YEAR AND A HALF R U SERIOUS I HAD TO REPLACE THE MOTOR AFTER A YEAR OF HAVIN THE CAR WHICH COST ME 1400ARS AND NOW A THROTTLE CONTROL SENSOR AND IT COST 746.00 WITH TAX AND 150 FOR THE LABOR MAN I SCREAMING NEED ANOTHER CAR BUT NOT FORD THEY LIED THEY R NOT BUILT FORD TOUGH UUUUUGGGGHHHHH. *TR
Apr 05, 2014
MY WIFE WAS GOING TO WORK AND THE ACCELERATOR STUCK. SHE GOT THE CAR SLOWED DOWN AND OFF THE STATE HIGHWAY. SHE CALLED ME CRYING AND VERY SHOOK UP THAT MORNING AND FOR A COUPLE OF DAYS. SHE COULD HAVE BEEN IN A SERIOUS ACCIDENT OR EVEN KILLED. I CALLED THE FORD DEALER AND THEY WENT AND GOT THE CAR. AFTER CHECKING OUT THE PROBLEM, THEY SAID THE THROTTLE BODY WOULD HAVE TO BE REPLACED AT A PRICE OF $676.00 PLUS LABOR. THEY CALLED FORD MOTOR CO FOR FINANCIAL HELP AND THEY SAID THERE IS NO RECALL AND THEY CANNOT HELP. I DID NOT THINK THIS IS RIGHT. I KNOW THEY KNOW THEY HAVE A PROBLEM, BUT WON'T ACKNOWLEDGE IT. MY WIFE COULD HAVE BEEN KILLED OR SERIOUSLY INJURED. WE NEED SOME FINANCIAL HELP. *TR
Mar 24, 2014
TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH WITH THE CRUISE CONTROL ACTIVATED THE SAFE MODE ENGAGED WITHOUT WARNING AND DECELERATED. THE ENGINE AND TRANSMISSION LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THE THROTTLE BODY HAD TO BE REPLACED. THERE WAS A MANUFACTURERS RECALL FOR THE THROTTLE BODY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE RECALL WAS FOR THE CLEANING OF THE THROTTLE BODY ONLY AND NOT THE REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.
Dec 19, 2013
+ 66 more complaints for this component
POWER TRAIN
65 complaints
VEHICLE STOPS AND STARTS WITH A JERK. JUMPING CAUSING SLOW DOWN EVEN WHILE ON THE INTERSTATE. FORD IS AWARE OF THIS PROBLEM AND HAS DONE TO FIX IT. SEEMS LIKE EVERY FORD HAS THIS PROBLEM AT SOME POINT
Jan 02, 2021
I OWN A 06 FORD FIVEHUNDRED AND AT ONLY 100,000 MILES I BEGAN EXPERIENCING REALLY HARD DOWNSHIFTING AND SOMETIMES COMPLETE SLIP FROM GEAR SLAMMING BACK INTO GEAR AFTER ROLLING FREELY FOR A WHILE HAPPENS WHEN CAR REACHES NORMAL RUNNING TEMP WAS TOLD WHOLE TRANSMISSION NEEDS TO BE REPLACED SEEMS LIKE ALMOST EVERYONE WITH THIS VEHICLE REGARDLESS OF THE YEAR HAS THIS SAME PROBLEM
Oct 18, 2019
TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. WHILE DRIVING APPROXIMATELY 10 MPH, THE VEHICLE STALLED AND THE WRENCH WARNING INDICATOR FOR THE TRANSMISSION ILLUMINATED. THE CONTACT TURNED THE VEHICLE OFF AND BACK ON, BUT IT LOST ACCELERATION. ALSO, WHEN THE VEHICLE WAS PLACED IN DRIVE OR REVERSE FROM A PARK POSITION, IT LUNGED FORWARD AND THE BRAKES HAD TO BE APPLIED IMMEDIATELY. FURTHERMORE, THE VEHICLE STALLED FOUR TIMES SINCE IT WAS PURCHASED TWO MONTHS AGO. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING; HOWEVER, AN APPOINTMENT WAS SCHEDULED WITH DUNCAN FORD (19999 VIRGIL H GOODE HWY, ROCKY MOUNT, VA 24151) FOR AUGUST 26, 2019. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 102,797.
Aug 22, 2019
ON A 55 MPH ROAD WHEN YOU GO TO MAKE A RIGHT TURN AND ACCELERATE IT WOULD DOWNSHIFT AND MAKE A LOUD THUD LOUD ENOUGH TO MAKE CHANGE RATTLE AND IT'S ALMOST LIKE ALMOST LOCKS UP FOR A MINUTE YOU COULD LOOSE CONTROL WHILE TURNING BUT THAT'S JUST HOW IT STARTED NOW WHEN YOUR GOING DOWN A 55 MPH BACKROAD AND GO UP A HILL AND THE CAR DOWNSHIFTS IT DOES IT TOO MY CAR ONLY HAS 102,000 ON IT
May 24, 2019
TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. WHEN THE CONTACT PLACED THE VEHICLE IN REVERSE, IT ROLLED FORWARD AND STRUCK ANOTHER PARKED VEHICLE. THERE WAS NO DAMAGE TO EITHER VEHICLE AND NO INJURIES. A POLICE REPORT WAS NOT FILED. WHEN THE CONTACT TURNED OFF AND RESTARTED THE VEHICLE, IT OPERATED NORMALLY. TOM PECK FORD (LOCATED AT 13900 AUTOMALL DR, HUNTLEY, IL 60142, (847) 669-6060) WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 150,000. *TT CONSUMER WAS TOLD SOMETHING WAS WRONG WITH THE AIR BAG BY THE DEALER TOM PECK. *JB
Nov 05, 2018
+ 60 more complaints for this component
SERVICE BRAKES, HYDRAULIC
24 complaints
TL*THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. THE CONTACT STATED THE BRAKE PEDAL NEEDED TO BE DEPRESSED TO THE FLOOR IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY ATTEMPTED UNSUCCESSFULLY TO DIAGNOSE THE FAILURE TWENTY TIMES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS 85,600 AND THE FAILURE MILEAGE WAS 73,000. UPDATED 06/06/11 *BF UPDATED 09/19/11
May 09, 2011
TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. THE CONTACT WAS DRIVING IN REVERSE AT AN UNKNOWN SPEED. AS THE CONTACT APPLIED THE BRAKES, THE VEHICLE WOULD NOT RESPOND AND HIT A SHOPPING CART, WHICH IN TURN THE CART HIT ANOTHER VEHICLE. A POLICE REPORT WAS FILED BUT NO INJURIES WERE REPORTED. THE FAILURE WAS NOT DIAGNOSED. APPROXIMATELY FOUR MONTHS LATER WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT APPLIED THE BRAKES AND EXPERIENCED AN INCREASE IN STOPPING DISTANCE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS TOLD THAT THE REAR BRAKE PADS WOULD NEED TO BE REPLACED AS THE PADS AND ROTORS HAD WORN OUT. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 15,000 AND THE CURRENT MILEAGE WAS 16,000. UPDATED 05/24/11*LJ UPDATED 08/10/11
Apr 27, 2011
1, PURCHASED MAY 2006 2, JULY 2007 LETTER FROM FORD EXTENDING WARRANTY ON REAR BRAKES. 3,MAY 2008 FORD REPLACED REAR BRAKES UNDER RECALL # 07N10N. 23,927 MILES ON CAR. 4, REAR BRAKES REPLACED 50,085 MILES 5, THE BRAKES REPLACED UNDER RECALL WERE THE SAME POOR QUALITY AS THEY REPLACED. 6, DEALER OFFERED NO HELP. 7, FORD SAID THAT ALL THEY WILL DO. 8,I FEEL THEY SHOULD REPLACE THE BRAKES WITH BETTER BRAKES THAT THE POOR QUALITY THEY USED ON THE RECALL. *TR
Mar 22, 2011
I HAVE A 2006 FORD 500 THE DEALER REPLACED MY REAR BRAKES AT 14,000 MILES N/C. AT 28,000 I PAID FOR BOTH REAR & FRONT BRAKES ROTORS AND CALIPERS, AT 52,000 MILES REAR & FRONT PADS I WAS JUST TOLD AT 76,000 I NEED THE WORKS AGAIN. *TR
Oct 30, 2009
I OWN A 2006 FORD FIVE HUNDRED WHICH I PURCHASED USED WITH APPROX. 12000 MILES. PRIOR TO THE PURCHASE FORD RECALLED IT AND PUT NEW BRAKE PADS AND ROTORS ON THE REAR. IT NOW HAS 29000 MILES ON IT AND THE REAR PADS ARE WORN OUT AND FORD SAYS THE ROTORS NEED REPLACING. THE BRAKES DRAG IN THE REAR. FORD SAYS THEY ARE NOT RESPONSIBLE. I HAVE RESEARCHED ON LINE AND FOUND A LARGE NUMBER OF COMPLAINTS IDENTICAL TO MINE. THIS IS A MANUFACTURER DESIGN PROBLEM AND A SAFETY HAZARD SINCE THERE ARE REPORTS OF THE BRAKES WEARING COMPLETELY INTO THE ROTOR AND LOCKING CAUSING ACCIDENTS. THE OWNER HAS NO CLUE SINCE THEY WEAR OUT SO FAST. FORD SHOULD BE HELD ACCOUNTABLE FOR THEIR DESIGN FLAW BEFORE THERE ARE DEATHS CAUSED BY THIS FLAW. *TR
Sep 09, 2009
+ 19 more complaints for this component
ELECTRICAL SYSTEM
19 complaints
The contact owns a 2006 Ford Five Hundred. The contact stated while driving 50 MPH, the instrument cluster lights turned became inoperable. The contact veered to the side of the road. The contact stated that the instrument cluster lights illuminated after 5 minutes. The contact was able to continue driving. However, the failure reoccurred on four different occasions. The vehicle was taken to a local Pep Boys who was unable to duplicate the failure. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 60,000.
Aug 24, 2022
THIS IS A LONG ON GOING PROBLEM WITH THE ELECTRICAL PROBLEM THAT HAS BEEN GOING ON NOW FOR FIVE MONTHS. STARTED OUT HAVING THE BATTERY CLUSTER LIGHT ON & CHECK CHARGING SYSTEM. FOUND CHARGING A LITTLE LOW, HAD NEW ALTERNATOR INSTALLED. THEN WITH A WEEK, BATTERY, ENGINE LIGHT & AIRBAG LIGHT CLUSTER ARE ON, THEN THE FUN BEGAN, THEN ALL THE INSTRUMENT CLUSTER GOES OFF AND YOU HAVE NO TURN SIGNALS, NO FANS, NO RADIO, NO ELECTRIC WINDOWS, NO DOOR LOCKS AND NO BREAK LIGHTS, (BUT BREAK LIGHTS DO COME ON WHEN YOU APPLY BREAKS AND THE BACK-UP LIGHTS COME ON. THE SYSTEM CAN COME AND GO ON AND OFF WHILE MOVING AND SETTING STILL. HAVE HAD SYSTEM CHECKED AND CODED, THEY CAN NOT FIND A PROBLEM EXCEPT THAT IT IS A ELECTRIC PROBLEM, HAD ALL WIRING CHECKED, CLEANED. NO,FRAYED WIRE FOUNF AND NO DEFECTIVE COUPLING. AGAIN I GET IT A WIRE THAT IS GROUNDING AND CAUSING PROBLEM. ALL THE FUSES ARE OK AND KNOW HAVE BLOWN. THE ONLY THING I KNOW IS THIS PROBLEM WAS REPORTED TO FORD BACK IN 2006 OR 2007 AND THEY HAVE NOT PUT OUT ANY RECALL ON IT AND THERE DEALERS KNOW NOTHING ABOUT WHAT TO DO BUT THEY WILL TRY AND FIND IT AT WHERE HOURLY RATE AND IT COULD BE A HOUR OR SEVERAL HOURS TO FIND PROBLEM. AS I'VE SAID THIS IS ON GOING IT CLEAR UP AND LAST FOR A WEEK UP TO SIX WEEKS AT A TIME.
Dec 18, 2019
WHILE DRIVING, THE INSTRUMENT CLUSTER BOTTOMS OUT ON THE SPEEDOMETER, TACH, AND ALL OTHER WARNINGS - BACKUP LIGHTS COME ON AND THE INSTRUMENT PANEL LIGHTS GO OUT.. SOMETIMES IT WILL COME BACK ON BY PRETTY QUICKLY, OTHER TIMES IT WILL BE THAT WAY FOR A WEEK OR MORE. THIS IS VERY DANGEROUS AND FROM RESEARCH I'VE DONE IS HAPPENING TO MANY PEOPLE. WHY HAS THERE NOT BEEN A RECALL TO FIX THE PROBLEM? THERE IS A TSB 06-17-9 DATED 9/4/2006 BUT NO REMEDY BY FORD. ALSO AFTER HAVING THE TRANSMISSION FLUID CHANGED AT THE RECOMMENDED MILEAGE THE TRANSMISSION THEN STARTED SLIPPING AND HAD TO EVENTUALLY BE REPLACED.
Dec 04, 2017
I WASING A WERE THERE WAS A RECALL ON MY CARE UNTELL SOMEONE TOLD ME. *TR
Mar 19, 2015
CLUSTER CONSTANTLY GIVES OUT, THERE IS A RECALL IN PLACE FOR THE 2005 VERSION WHICH HAS THE SAME ISSUE BUT NOT THE 2006. THE CLUSTER HAS BEEN REPLACED TWICE ALREADY, EVERYTHING SUDDENLY STOPS WORKING HAVE RECEIVED NUMEROUS TICKETS AT THIS POINT FOR GOING OVER THE SPEED LIMIT BECAUSE OF THIS ISSUE ALL CLUSTER GAUGES STOP WORKING THERE IS NO WAY TO NO HOW FAST YOU ARE GOING. *TR
Feb 27, 2015
+ 14 more complaints for this component
UNKNOWN OR OTHER
12 complaints
I would be driving on highway my wrench light would come on and my car would come to a crawl I always have kids in my car I could easily be rear ended and maybe hurt or killed I have to find a place to pull off where people behind me is cussing me out they think I did on purpose I then shut car off and tirn back on. Then ok till happens again there should be a recall I am on a fixed income and can't afford another car please help
Aug 27, 2022
Door latch freezes i cold weather causing the door not to latch closed.
Jan 21, 2022
THROTTLE BODY DEFECTED WENT OUT SHUT DOWN CAR WHILE DRIVING AT HIGH SPEED BUSY STREET MICHIGAN AVE DEARBORN, MI. NO RECALLS OR ASSISTANCE AVAILABLE, AFTER RESEARCH IS KNOWN DEFECT AND BAD PART.
Jan 12, 2016
I WAS GOING ALONG AND ALL OF THE SUDDEN MY CAR CAME TO A DEAD STOP AND I COULD HAVE BEEN HIT FROM BEHINDI ENDED UPHAVING TO HAVE A FUEL PUMP COST 676.00 AND THEN IT KEPT DYING ON ME AND THE ENGINE LIGHT CAME ON TOOK IT IN AND ENDED UP HAVING TO HAVE A THROTTLE BODY COST 938.00. SOME ONE TOLD ME THE SAME THING HAPPEN TO THEM AND THEY SENT FORD THE RECEIPT AND THEY REIMBURSED THEM THE AMOUNT THEY HAD PAID.
Jul 30, 2015
DEAR SIR/MADAM, I HAVE A 2006 FORD FIVE HUNDRED AND HAS ABOUT 93K MILES ON IT.VIN # [XXX] . I TAKE GOOD CARE OF THE CAR AND HAVE NEVER MISSED ANY SERVICE. I ALWAYS HAD A KNOCKING SOUND ON TURNING ON AND TURNING OFF THE AC. (I HAD CHECKED A DEALER ONCE IN NEW YORK AND I WAS TOLD "WE ALL MAKE SOME NOISE" ANYWAYS, A WEEK AGO SUDDENLY THE AC HAS STOPPED WORKING ON IDLING AND ONLY WORKS WHEN THE CAR IS MOVING. I WAS SHOCKED WHEN I GOOGLED THE PROBLEM TO SEE HOW MANY PEOPLE HAVE BEEN HAVING THIS PROBLEM. ISN'T THERE A RECALL FOR 2006 FORD FIVE HUNDRED AC ? FOLLOWING ARE THE LINKS TO THE WEB PAGES SHOWING THE PROBLEMS PEOPLE ARE HAVING: HTTP://COMMUNITY.CARTALK.COM/DISCUSSION/2120935/FORD-FIVE-HUNDRED-A-C-PROBLEMS/P4 HTTP://WWW.CARCOMPLAINTS.COM/FORD/FIVE_HUNDRED/2006/AC_HEATER/BAD_AC_COMPRESSOR.SHTML I HAVE VERY SPARINGLY USED THE AC IN MY CAR AND AM CERTAINLY DISAPPOINTED WITH THE POOR QUALITY OF INSTALLED PARTS. I AM REQUESTING A FREE REPAIR OF THE ISSUE. IF NOT THEN I WILL TRY AND CONTACT SOME OTHER PEOPLE AND CONVINCE THEM FOR A COLLECTIVE ACTION. [XXX] ARE YOU THE OWNER OF THE VEHICLE :YES VIN : [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Oct 09, 2014
+ 7 more complaints for this component
STRUCTURE
11 complaints
TRANSMISSION IS FAULTY. SHORTLY AFTER I BOUGHT THIS CAR USED AT 91000 MILES I HAD TO REPLACE VALVE SOLENOID AND REPROGRAM COMPUTER DONE BY FORD DEALERSHIP. THIS WORKED FOR ABOUT 2 TO 3 MONTHS AT WHICH POINT THE TRANSMISSION STARTED ACTING UP AGAIN. IT WOULD STALL AND THEN SHIFT REALLY HARD WHEN COMING UP TO SPEED WHICH RESULTED IN A JERKING OF THE CAR. ALSO WOULD JERK WHEN TRYING TO COME TO A STOP. I HAD A FEW CLOSE CALLS WHICH ALMOST RESULTED IN AN ACCIDENT SINCE I CAN NOT SPEED UP WITHOUT IT JERKING AND I COULDN'T SLOW DOWN FAST WITHOUT IT JERKING AND WANTING TO JUMP FORWARD. I HAVE PUT AN AFTERMARKET INLINE TRANSMISSION FILTER IN AND HAVE TO CHANGE THE FILTER AND FLUID EVERY 2500 TO 3500 MILES. WHEN I DO THIS IT HELPS FOR A SHORT PERIOD AND THEN IT ACTS UP AGAIN. I KNOW THIS IS ONLY A TEMPORARY FIX AND I WILL EITHER END UP IN A CRASH OR HAVING TO REPLACE THE WHOLE TRANSMISSION EVENTUALLY. *TR
Sep 30, 2014
THE FRONT LIP OF THE HOOD HAS PAINT PEELING OFF. *TR
May 03, 2014
ALL FOUR DOORS FILL WITH WATER. *TR
May 03, 2014
TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER FOR ROUTINE SERVICE WHEN HE WAS ADVISED THAT THE HOOD LATCH WAS RUSTED. THE MECHANIC ADVISED THAT IF THE RUST CONTINUED TO EXPAND, THE LATCH WOULD FAIL AT ANY GIVEN TIME AND COULD OCCUR WHILE THE VEHICLE WAS IN MOTION. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 152,000.
Jan 15, 2013
FRONT DRIVER FLOOR BOARD LEAKS WATER, ESPECIALLY WHEN THERE IS HUMID WEATHER. *TR
Jul 27, 2011
+ 6 more complaints for this component
POWER TRAIN,VEHICLE SPEED CONTROL
10 complaints
IN MULTIPLE INCIDENTS, ON HOT SUMMER DAYS, THE CAR HAS SUDDENLY ACCELERATED (WITH NO FOOT ON THE ACCELERATOR) WHEN BACKING OUT OF PARKING SPACES AND SOMETIMES WHEN PUT INTO DRIVE RIGHT AFTER THE SUDDEN ACCELERATION IN REVERSE. IT HAS REQUIRED RAPID, FIRM BRAKING TO PREVENT THE CAR FROM HITTING OTHER VEHICLES. ABOUT A WEEK AFTER THE PROBLEM STARTED WITH THIS CAR, IT STARTED TO HAPPEN OCCASIONALLY WITH MY OTHER FORD FIVE HUNDRED (A 2005 MODEL WITH A LITTLE LESS MILEAGE). A SEPARATE COMPLAINT HAS BEEN FILED ON THAT VEHICLE. RESEARCH ONLINE HAS REVEALED THAT HUNDREDS OF FORD FIVE HUNDRED OWNERS HAVE REPORTED THIS ISSUE AND THAT THE THROTTLE BODY IS THE LIKELY CULPRIT. *TR
Sep 16, 2012
TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE REVERSING, THE VEHICLE LUNGED BACKWARD. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSIS AND THE THROTTLE CONTROL WAS REPLACED. THE MANUFACTURER WAS NOTIFIED, BUT OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE 71,229. ....UPDATED 08-24-12 *BF THE CONSUMER SHIFTED THE VEHICLE INTO DRIVE IT THEN WENT INTO SAFE DRIVE MODE. WHEN THE VEHICLE WAS IN REVERSE THE CONSUMER DEPRESSED THE BRAKE WITH BOTH FEET TO NO AVAIL. 08/30/2012 *JS
Jul 27, 2012
THE VEHICLES WARNING INDICATOR LIGHT OF A WRENCH LIT UP INDICATING TRANSMISSION/THROTTLE BODY SERVICE. HAD PREVIOUSLY HAD TRANSMISSION INSPECTED AND WERE NO PROBLEMS. THE CAR WILL THRUST IN DIRECTION CAR IS IN GEAR OF SUCH AS WHEN CAR IS IN REVERSE IT WILL THRUST AND LUNGE BACKWARDS ALSO IN DRIVE LUNGE FORWARDS. IT ALSO IS ENHANCED WHEN THE CARS HEATER OR A/C IS RUNNING. HAVE RESEARCHED AND MANY, MANY PEOPLE HAVE HAD SIMILAR PROBLEMS AND COMPLAINTS. *TR
Oct 30, 2011
I'M NOT SURE IF THIS IS A POWER TRAIN OR OTHER PROBLEM, CAR LURCHES DANGEROUSLY AT LOW SPEEDS, AND WHEN CHANGING GEAR INTO AND OUT OF REVERSE. I HIT A POST PARKING IN AUGUST OF 2010 DUE TO THIS, AND IT'S BEEN GETTING GRADUALLY WORSE. TOOK IT TO THE DEALER WHO REPLACED A BROKEN UPPER MOTOR MOUNT THAT WAS CONNECTED TO THE TRANSMISSION. DIDN'T HELP, ALTHOUGH IT SEEMED LIKE A GOOD GUESS AT THE TIME. IT HELPS TO KEEP FOOT FIRMLY ON BRAKE WHEN CHANGING GEAR OR HOLDING STILL, WHILE THE CAR TRIES TO LURCH FORWARD (OR BACK) WITH UNPLANNED ACCELERATION. SEEMS TO BE GETTING INCREASINGLY WORSE AND NOW I DON'T FEEL IT'S SAFE TO LET ANYONE ELSE DRIVE IT, LIKE AT VALET PARKING. TAKING IT BACK TO DEALER TOMORROW, BUT WE LET WARRANTY EXPIRE RECENTLY DARN IT. WE GET SO MANY FAKE SPAM WARRANTY-EXPIRING PHONE CALLS THAT I GOT CONFUSED AND DROPPED THE BALL. THROTTLE CONTROL MODULE MAY BE GIVING FALSE SIGNAL TO CARBURETOR, NOT SURE WHAT IT IS. *KB
Oct 12, 2011
THE CAR LUNGES IN DRIVE AND REVERSE WITHOUT ACCELERATING. THIS IS DANGEROUS AS WHEN BACKING OUT OF GARAGES OR PARKING PLACES. TRYING TO TAKE OFF SLOWING IS NOT POSSIBLE. *KB
Sep 19, 2011
+ 5 more complaints for this component
ENGINE AND ENGINE COOLING
10 complaints
TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING WHILE DRIVING 30 MPH. THE CONTACT DID NOT TAKE THE VEHICLE TO A DEALER OR LOCAL MECHANIC FOR DIAGNOSIS OR REPAIRS. THE FAILURE MILEAGE WAS 68,780.
Jan 20, 2012
LATELY MY 2006 FORD 500 HAS BEEN ACTING UP WHEN I START IT...SOME DAYS IT STARTS JUST FINE, OTHER DAYS IT WON'T START. IT DOESN'T MATTER THE TEMPERATURE OUTSIDE EITHER, IT MAY START IN THE MORNING & THEN WHEN IT'S TIME TO HEAD HOME AFTER WORK IT WON'T START OR VICE VERSA. THE DAYS IT WON'T START THE ONLY WAY I'VE FOUND TO GET IT TO START (WITHOUT JUMPING IT) IS TO TURN & HOLD THE IGNITION KEY ALL THE WAY DOWN WHEN I'M STARTING IT & GIVE IT GAS. TOOK IT TO THE DEALER THIS MORNING (11/23/11) TO FIND OUT THE PROBLEM. WE WERE THINKING POSSIBLY THE STARTER WAS NEEDING REPLACED...WE WERE WRONG. THE PROBLEM IS THAT THE THROTTLE BODY ISN'T WORKING PROPERLY & NEEDS REPLACED...AS WELL AS DOING AN INDUCTION SERVICE TO FLUSH OUT THE CARBON BUILD UP. THIS IS GOING TO COST ALMOST $1,000 TO FIX. ARE YOU KIDDING ME?? MERRY CHRISTMAS TO US!! AFTER RECEIVING THE CALL FROM THE DEALER'S SERVICE DEPT WE DID A SEARCH ONLINE & COME TO FIND OUT THAT THIS "THROTTLE BODY PROBLEM" IS COMMON IN THIS CAR. THOUGH WHEN WE BROUGHT IT TO THE SERVICE PERSON'S ATTENTION & QUESTIONED THEM ABOUT IT THEY COULDN'T/WOULDN'T ANSWER IF THIS WAS TRUE. NOT SURE BUT MAYBE THERE HASN'T BEEN ENOUGH PROBLEMS REPORTED TO HAVE A RECALL...BUT WITH ALL THE SAME ISSUES THAT I'VE FOUND ONLINE IT MAKES ME WONDER. WE'VE ALREADY REPLACED THE TRANSMISSION MAYBE 2 YEARS AFTER WE BOUGHT THE CAR..THANKFULLY THAT WAS STILL UNDER WARRANTY. WHAT ELSE CAN GO WRONG WITH THIS CAR!! WE HAVE BEEN FAITHFUL FORD CAR BUYERS..HOWEVER THIS 500 HAS TURNED US OFF FROM EVER BUYING ANOTHER FORD VEHICLE AGAIN. *TR
Nov 23, 2011
AC COMPRESSOR QUIT WORKING? *KB
Jul 21, 2011
AC AIR BLOWS COLD WHEN YOU ARE DOING 60 MPH ON THE HIGHWAY... AROUND TOWN IT IS HOT!!! DEALER RECHARGED THE SYSTEM, BUT STILL HAVE THE SAME PROBLEM. NOW BEING TOLD IT IS THE COMPRESSOR. SO MANY PEOPLE ARE HAVING THE SAME PROBLEM WITH THE A/C IN FORD FIVE HUNDREDS. THIS REALLY NEEDS TO BE LOOKED INTO PLEASE! *KB
Jul 21, 2011
WHILE RUNNING THE AIR CONDITIONER, THEN EITHER BRIEFLY SHUTTING OFF ENGINE OR IDLING IN PARK OR NEUTRAL, ONCE THE CAR IS SHIFTED INTO DRIVE GEAR THE ENGINE ACCELERATES ON ITS OWN, FOOT BREAK IS ON. RPMS INCREASE FOR 3-4 SECONDS THEN GO BACK DOWN TO NORMAL. THE CAR WAS UNABLE TO LURCH FORWARD ONLY BECAUSE I'VE HAD MY FOOT ON THE BREAK DUE TO MY SHIFTING OF GEARS (FROM PARK OR NEUTRAL TO DRIVE). THE FIRST TIME THIS HAPPENED I ONLY HAD THE BREAK PEDAL SLIGHTLY DEPRESSED - CAR JUMPED FORWARD - I FULLY DEPRESSED BRAKE PEDAL TO STOP. OCCURS INTERMITTENTLY BUT INTENSITY OF SURGE INCREASING. YESTERDAY HAD A MUCH STRONGER SURGE IN DRIVE-THRU, THEN CAR STALLED. WAS ABLE TO RESTART, ENGINE LIGHT HAS REMAINED ON SINCE YESTERDAY'S INCIDENT. TOP MOTOR MOUNT DAMPER (ROUND RUBBER DISK) IS CRACKED THRU AS WELL, PROBABLY DUE TO LURCHING.
Jul 14, 2011
+ 5 more complaints for this component
FUEL SYSTEM, GASOLINE
8 complaints
THE ENGINE SURGES WHEN YOU PUT IN DRIVE OR REVERSE. THIS IS VERY DANGEROUS. THIS IS MY WIFE'S CAR AND THIS PROBLEM HAS ME CONCERNED ABOUT HER SAFETY EVERY TIME SHE GETS IN THIS CAR. I THOUGHT ABOUT GETTING RID OF IT BUT I COULDN'T LET SOMEONE ELSE HAVE A CAR WITH THIS DANGEROUS PROBLEM. I HOPE SOMEONE CAN FIND OUT WHAT THE REMEDY IS FOR THIS PROBLEM. PLEASE HELP. *TR
Jul 17, 2011
A FUELD DELIVERY SYSTEM ISSUE ON MY 2006 FORD FIVE HINDRED. THE ENGINE ACCELERATES THE VEHICLE DURING LOW SPEEDS IN FORWARD AND REVERSE, WHILE APPROACHING AN INTERSECTION WITH FOOT ON BRAKE. THIS HAS HAPPEND 4 TIMES IN THE LAST WEEK.
Jul 15, 2011
MY FORD 500 LUNGES FORWARD WHEN APPLYING BRAKE OR GOING INTO REVERSE. I READ ABOUT THE FREESTYLE INVESTIGATION ON LUNGING AND MY 500 IS DOING THE VERY SAME THING. INVESTIGATION NEEDS TO BE DONE ON THE 500 AS WELL BECAUSE IT SEEMS I'M NOT THE ONLY ONE WITH THIS PROBLEM. *TR
May 23, 2011
I HAVE A "BUCKING" BEHAVIOR, AFTER TRAVELING APPROXIMATELY 2 HRS AT SPEEDS OVER 60MPH (INTERSTATE TRAVEL). THE CAR WOULD LURCH SEVERELY AND HESITATE, THE ENGINE REVVED VERY LOUDLY, AND THE SPEED REDUCED TO 40 MPH, EVEN THOUGH I HAD MY FOOT TO THE FLOOR ON THE GAS PEDAL. AFTER DRIVING OFF THE HIGHWAY, IT WOULD DO THE SAME THING AT CITY SPEEDS AND HAD LITTLE TO NO ACCELERATION. DEALER SAID THE CODES SHOWED IT WAS THE FUEL PUMP AND IT WOULD DO THE BUCKING AND LACK OF ACCELERATION AFTER THE PUMP HEATED UP. DEALER SAID THE CAR WAS UNSAFE TO DRIVE. THE FUEL PUMP, FUEL FILTER HAD TO BE REPLACED, AND THE INJECTORS FLUSHED. *TR
Mar 07, 2011
THE FUEL LINE SEPARATED FROM THE GAS FILTER, WHICH CAUSED GASOLINE TO SPILL EVERYWHERE. FIRE DEPARTMENT WAS CALLED, AS LEAKING FUEL WAS A HAZED. DEALER REPLACED THE BROKEN FUEL LINE CLIP AT THE FUEL FILTER. *TR
Mar 06, 2011
+ 3 more complaints for this component
VEHICLE SPEED CONTROL,ENGINE
7 complaints
TL* THE CONTACT OWNS A 2006 FORD 500. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SUDDENLY STOPPED ACCELERATING. AFTER RESTARTING THE ENGINE, THE VEHICLE OPERATED NORMALLY. DURING THE FAILURE, THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS EXAMINED BY AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE THROTTLE BODY WAS FAULTY. THE VEHICLE WAS NOT REPAIRED. THE LOCAL DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 94,000.
Dec 20, 2018
TL* THE CONTACT OWNS A 2006 FORD 500. ON MANY OCCASIONS, THE VEHICLE FAILED TO START. ONCE THE VEHICLE WAS STARTED, IT FAILED TO ACCELERATE FORWARD. THE VEHICLE WAS EXAMINED BY AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE THROTTLE BODY WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE LOCAL DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 190,000.
Oct 24, 2018
ENGINE SHUT OFF WHILE DRIVING. FAULT CODE INDICATES THROTTLE CONTROL PROBLEM, BUT CAR DRIVES NORMALLY AFTER RESTARTING. WHEN WILL IT SHUT OFF AGAIN? IS IT SAFE TO DRIVE TO THE FORD DEALER? *TR
Nov 21, 2014
MY CAR MAKES HARSH JERKING MOTION WHILE I AM DRIVING. THE MOTION OCCURS INTERMITTENTLY SO I AM UNABLE TO PREDICT WHEN IT WILL OCCUR. HOWEVER, IT DOES HAPPEN WHILE THE CAR IS IN AN MOTION AND UPON ACCELERATION. AFTER FIRST EXPERIENCING THE PROBLEM. THE MOTOR MOUNT OF THE VEHICLE WAS REPAIRED. THIS SEEMED TO REMEDY THE PROBLEM FOR ABOUT TWO WEEKS, THEN THE PROBLEM PERSISTED. NOT AS HARSH AS PREVIOUSLY BUT NONETHELESS, THE RIDE FEELS UNSAFE AND THE ISSUE HAPPENS ERRATICALLY. THIS PROBLEM HAS CONTINUED FOR OVER A YEAR. DURING THIS TIME I HAVE RESEARCHED ONLINE TO FIND THAT THIS IS A COMMON ISSUE AND COMPLAINT AMONG CONSUMERS. WHY HAS THIS VEHICLE NOT BEEN RECALLED? THIS IS A PRESSING ISSUE FOR ME AS IT IS NOT A SECURE FEELING TO LOSE CONTROL OF YOUR VEHICLE MOMENTARILY. I ALSO HAVE TO CONSIDER THE SAFETY OF MY UNBORN CHILD. THE FORD FIVE HUNDRED VEHICLES WITH MAJOR MECHANICAL MALFUNCTIONS NEED TO BE RECALLED AND TAKEN OFF THE MARKET, NOT SIMPLY "FIXED." AFTER A FIRE OR MAJOR ACCIDENT HAS TAKEN PLACE, IT IS EVIDENT THAT "FIXING" THE CARS IS NOT THE BEST SOLUTION. *TR
May 11, 2014
CAR ACCELERATES SUDDENLY WITHOUT HAVING FOOT ON ACCELERATOR. IT ONLY HAPPENS IN WARM WEATHER WHEN THE AIR CONDITIONING IS ON. WITH MY FOOT ON THE BREAKING WHEN BACKING OUT OF A PARKING SPACE OR PULLING INTO GARAGE THE CAR SUDDENLY ACCELERATES. I CAN HANDLE THE PROBLEM BECAUSE I KNOW WHEN TO EXPECT IT, BUT I HAD PLANNED TO GIVE THIS CAR TO MY SOON TO BE LICENSED DAUGHTER AND I DON'T WANT HER HAVING AN ACCIDENT OR HITTING ANOTHER PERSON. *TR
Jul 26, 2012
+ 2 more complaints for this component
EQUIPMENT
7 complaints
I NOTICED A LEAK UNDER MY VEHICLE AND DISCOVERED THE AIR CONDITIONER COMPRESSOR LEAKING. I AM PREPARING TO TAKE IT TO THE DEALER FOR REPAIRS. I AM AWARE THAT THE SAME PROBLEMS EXIST ON NUMEROUS 2005 AND 2006 MODELS. I HOPE THAT FORD WILL TAKE SOME ACTION TO ASSIST THE MANY CUSTOMERS WITH THE SAME PROBLEM. I BELIEVE A RECALL IS REQUIRED! *JS
Jul 02, 2012
TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE AIR CONDITIONING UNIT FAILED AND WOULD NOT BLOW COLD AIR. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO ADDED COOLANT TO THE AIR CONDITIONING SYSTEM BUT THE FAILURE WAS NOT CORRECTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 100,000.
Apr 27, 2012
TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE DRIVING 70 MPH WITH THE AIR CONDITIONER TURNED ON, SHE NOTICED THAT IT WOULD NOT BLOW OUT COLD AIR. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 59,000. UPDATED 12/6/11*LJ UPDATED 12/14/11
Sep 20, 2011
AC AIR BLOWS COLD WHEN YOU ARE DOING 60 MPH ON THE HIGHWAY... AROUND TOWN IT IS HOT!!! DEALER RECHARGED THE SYSTEM, BUT STILL HAVE THE SAME PROBLEM. NOW BEING TOLD IT IS THE COMPRESSOR. SO MANY PEOPLE ARE HAVING THE SAME PROBLEM WITH THE A/C IN FORD FIVE HUNDREDS. THIS REALLY NEEDS TO BE LOOKED INTO PLEASE! OLD ODI ID NUMBER : 10414022 *TT
Jul 22, 2011
AIR CONDITIONING UNIT STARTED MAKING NOISES LAST YEAR (APPROX. AUGUST). TOOK IT TO THE DEALERSHIP AND THEY TOLD ME THE COMPRESSOR WAS GOING. THEY ALSO SAID THERE ARE SO MANY PROBLEMS WITH THAT COMPRESSOR THAT THEY WOULD NOT BE ABLE TO GET ONE UNTIL FEBRUARY. *KB
Jul 18, 2011
+ 2 more complaints for this component
ELECTRICAL SYSTEM,EXTERIOR LIGHTING
5 complaints
when I’m The vehicle and the temperature reaches middle temp ,the car starts to beep and all the dashboard lights go completely out and the head lights and tail lights be blinking as if they are about to go off . Even when I have the heater or a/c on they turns off and I’m a afraid that if or when I’m on the highway all my lights will just stop working on the middle of the highway at night and no one will be able to see me. And that will cause a big wreck and maybe kill myself or worst someone else. I have looked my car up to see if it has a recall but none are given. I’m afraid for the safety of my fellow drivers on the at night . And I don’t know what to do about this problem.
Dec 25, 2021
CAUSE UNKNOWN- BATTERY LIGHT IS COMING ON MORE WHILE VEHICLE IS RUNNING IN ALL MODES, LOCAL AUTO STORE DETERMINED IT IS AN ELECTRICAL PROBLEM. THEY TESTED THE BATTERY, ALTERNATOR & STARTER. ALSO NOTICED THAT THERE IS A MUSTY SMELL & MANY ( IF NOT ALL) OF MY METAL PARTS ARE RUSTED.
Jan 07, 2020
TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE REAR DRIVER SIDE TAIL LIGHT FAILED TO ILLUMINATE. WHEN THE VEHICLE WAS PLACED IN REVERSE, THE REVERSE LIGHTS FAILED TO ILLUMINATE. IN ADDITION, THE CONTROL PANEL AND DRIVER SIDE BLINKERS FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ALTERNATOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURES RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.
Oct 12, 2016
CPSC: I1390188A. 2006 FORD FIVE HUNDRED. CONSUMER STATED THE LEFT FRONT HEAD LIGHT CAUGHT ON FIRE SPONTANEOUSLY WHILE HAVING BEEN PARKED FOR 30 MINUTES IN THE GARAGE AND ENGINE WAS OFF. *LN THE FIRE DESTROYED THE LEFT FRONT ENGINE AREA. THE VEHICLE WAS TOTALED BY THE INSURANCE COMPANY.
Oct 22, 2013
LOW BEAM HEADLAMP SOCKET ON THE DRIVERS SIDE FAILED. ONE OF THE SOCKET CONTACTS SHOWED EVIDENCE OF A CATASTROPHIC ELECTRICAL FAILURE - LOOKS LIKE SEVERE ARCING, BURNED PLASTIC, BROKEN SOCKET SHELL AND BADLY BURNED PIN IN THE LAMP. THE LAMP ITSELF IS STILL O.K., EXCEPT FOR THE BADLY BURNED PIN. ABOUT A WEEK AND A HALF LATER THE SAME THING HAPPENED TO THE LOW BEAM LAMP ON THE PASSENGER SIDE. SAME DAMAGE TO THE SAME PIN IN THE SOCKET. THAT LAMP IS ALSO O.K. EXCEPT FOR THE BURNED PIN. THIS WOULD APPEAR TO BE A PROBLEM WITH THE SOCKETS/VEHICLE WIRING, NOT THE LAMPS. THESE LAMPS ARE MOUNTED QUITE HIGH AND ARE REASONABLY WELL PROTECTED SO IT IS UNLIKELY THAT THIS IS A MOISTURE PROBLEM. THE COST OF THE REPLACEMENT SOCKET FROM FORD IS SIMPLY OUTRAGEOUS! DEALER SAYS THIS IS THE FIRST CASE THEY'VE SEEN OF THIS HAPPENING - BUT I HEARD THE SAME THING WHEN I HAD PROBLEMS WITH THE REAR BRAKES AND I NOW KNOW THAT CERTAINLY WASN'T TRUE! HAS ANYONE ELSE HAD THIS PROBLEM? *TR
Nov 02, 2008
POWER TRAIN,ENGINE
4 complaints
The contact owns a 2006 Ford Five Hundred. The contact stated while driving at various speeds, the transmission was slipping. The contact restarted the vehicle and the transmission worked as designed for a while. While traveling up a hill or at a stop light, the vehicle would drift backwards. The contact had to let the vehicle drift to shift into gear. At times the vehicle failed to shift. The engine and wrench warning lights were illuminated. The contact was concerned about driving the vehicle. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 140,000.
Nov 19, 2021
TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE VEHICLE HAD AN UNEXPECTED ACCELERATION AS THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT WAS UNABLE TO STOP THE VEHICLE OR PLACE IT IN REVERSE WHEN THE FAILURE OCCURRED. AS A RESULT, THE CONTACT CRASHED INTO ANOTHER VEHICLE. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES REPORTED. ADDITIONALLY, THE CONTACT MENTIONED THAT THE VEHICLE FAILED TO ACCELERATE OUT OF FIRST GEAR. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 56,000.
Feb 24, 2015
FROM THE DAY I BOUGHT THE CAR THE A/C HAS NOT WORKED PROPERLY. IT ONLY COOLS AT HIGHWAY SPEEDS OR WHEN TEMPERATURE OUTSIDE IS LESS THAN 70 DEGREES, THE ENGINE HAS NEVER IDLED SMOOTHLY AND WATER COLLECTS IN THE DOORS. THE MAIN ISSUE I'VE BEEN HAVING IS THAT IT SURGES AT STOP LIGHTS AND TOTALLY SHUTS DOWN GOING DOWN THE ROAD. MOTOR, GAUGES EVERYTHING SHUTS DOWN SOMETIMES FOR 8-10 SECONDS. THIS IS SPORADIC AND MORE COMMON WHEN THE A/C IS IN USE. I HAVE HAD THE THROTTLE BODY CLEANED AND REPROGRAMMED SEVERAL TIMES WITH NO CHANGE WHAT SO EVER. I JUST HAD A NEW ONE INSTALLED AND IT SHUT DOWN ON ME WITHIN 1 MILE OF DEALERSHIP. IT HAS BEEN VERY FRUSTRATING TO SAY THE LEAST. I'VE BEEN SAYING IT IS SOMETHING WITH THE A/C SINCE DAY ONE BUT ALL THEY WANTED TO DO IS REPLACE THE THROTTLE BODY. I AM AT MY WITS END AND JUST WANT IT FIXED! *TR
May 06, 2014
WHILE DRIVING DOWN STREET AFTER A COLD START, CAR STARTED TO DRIVE SLOW, MADE A NOISE FROM LEFT SIDE OF ENGINE COMPARTMENT, AND WRENCH LITE CAME ON ALONG WITH THE ENGINE LITE. I SCANNED FOR THE OBDII CODE AND IT PRESENTED CODE P0942. I ERASED THE CODE TO SEE WHAT WOULD HAPPEN. LEFT IT ALONE UNTIL THE NEXT DAY. NOW, WHEN STARTED, THERE IS A FAULTY BEARING NOISE WHICH IS PRESENT UNTIL TRANSMISSION IS ENGAGED IN EITHER REVERSE OR DRIVE. I WOULD PULL CAR FORWARD TEN FEET AND BACK IN REVERSE TO PARK. WHEN I DO THIS, NOISE GOES AWAY. AFTER DOING THIS FIVE (5) DAYS IN A ROW, I DRIVE CAR AROUND A CITY BLOCK. I COULD ONLY HEAR NOISE FAINTLY. NO WRENCH LITE OR ENGINE LITE CAME BACK DURING THIS SMALL DRIVE. I HAVE NOT DRIVEN CAR SINCE RESEARCH OF CODE P0942 POINTED TO THE TRANSMISSION. I ONLY START CAR NOW BECAUSE OF THE COLD WISCONSIN WEATHER. MY CONCERN NOW IS IF THERE IS A RECALL FOR THIS CVT TRANSMISSION? *TR
Feb 01, 2014
ENGINE
4 complaints
TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. WHILE DRIVING 60 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED AND THE VEHICLE BEGAN TO LOSE POWER WITHOUT WARNING. THE VEHICLE WAS PULLED OVER TO A SHOULDER LANE, RESTARTED, AND RETURNED TO NORMAL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT ALSO STATED THAT THE THROTTLE BODY AND ENGINE WERE PREVIOUSLY REPLACED. THE FAILURE OCCURRED RANDOMLY. THE LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN ANY RECALLS. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.
Jan 11, 2018
TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT DETECTED A BURNING ODOR INSIDE THE VEHICLE. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD. THE CONTACT OPENED THE HOOD AND NOTICED THAT THE TOP OF THE MANIFOLD IGNITED INTO FLAMES AND THE MOTOR MOUNT WAS DRY ROTTED. THE CONTACT MANAGED TO EXTINGUISH THE FIRE WITH A PERSONAL FIRE EXTINGUISHER. AN INDEPENDENT MECHANIC STATED THAT THE ENTIRE MOTOR MOUNT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS UNAVAILABLE.
Aug 28, 2014
THIS VEHICLE HAS HAD A SURGING AND STALLING ISSUE EVER SINCE IT WAS PURCHASED. IT WOULD COME AND GO THROUGHOUT THE YEARS BUT GOT MUCH WORSE RECENTLY. WHEN STOPPED AT A LIGHT FOR INSTANCE THE IDLE SPEED BECOMES LOW AND SOMETIMES STALLS. IT WILL SURGE MAKING SLOW TURNS AND SURGE WHEN PUT INTO DRIVE. IT WILL SURGE FORWARD WHEN TURNING INTO A PARKING SPOT AND IN MANY OTHER INSTANCES. IF YOU ARE IN DRIVE AND PUT IT INTO PARK THE RPM WILL ALSO SURGE AS HIGH AS 2500. SINCE I HAVE BEEN READING UP ON THE ISSUE I NOTICED THAT THERE WAS A LETTER SENT OUT TO OWNERS OF MY MODEL WHICH I DID NOT RECEIVE. THE PROBLEM WAS SUPPOSED TO BE ADDRESSED FOR FREE PER R12N03. OF COURSE THE COVERAGE ENDED ON 03/31/2013. I DID NOT RECEIVE THIS NOTICE AND SHOULD STILL BE ABLE TO GET THIS REPAIR DONE FOR FREE. IT SHOULD BE A RECALL. *TR
Jul 02, 2014
TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE STALLED WITH THE ILLUMINATION OF THE WRENCH WARNING LAMP. THE FAILURE WAS EXPERIENCED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING, WHICH LOCATED THE FAILURE AT THE EGR VALVE. THE EGR VALVE WAS REPLACED BUT THE FAILURE WAS NOT CORRECTED. THE VEHICLE CONTINUED TO STALL WHILE DRIVING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 127,500 AND THE CURRENT MILEAGE WAS 127, 6000.
Jun 11, 2012
STEERING
4 complaints
AS MY WIFE AND I WERE DRIVING THE CAR ON SEPARATE OCCASIONS WE NOTICED INCONSISTENCY IN THE RESPONSIVENESS OF THE STEERING WHEEL. SOMETIMES IT WAS DIFFICULT TO TURN, OTHER TIMES IT TURNED FREELY. THIS COULD HAVE CAUSED MAJOR PROBLEMS WHILE DRIVING. NOW THE STEERING WHEEL HAS BECOME NEARLY IMPOSSIBLE TO TURN AT ALL TIMES. WE TOOK IT TO A MECHANIC WHO SAID IT WAS THE LOWER STEERING SHAFT COUPLING AND IT WAS NEARLY LOCKED UP. HE INFORMED US THAT THIS IS A VERY COMMON PROBLEM WITH FORD PRODUCTS. IF THIS IS A PROBLEM WITH MANY FORD PRODUCTS, WHY ISN'T IT BEING RECALLED? THIS IS A POINT OF FAILURE THAT COULD COST AN ENTIRE FAMILY THEIR LIVES. FORD REALLY NEEDS TO STEP UP AND TAKE CARE OF THIS MATTER BEFORE LIVES ARE LOST DUE TO POOR DESIGN AND INCOMPETENCE. *TR
Feb 04, 2015
TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SWERVED INTO THE NEXT LANE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 88,000.
Jan 30, 2015
STEERING BINDS WHILE TURNING FORCING DRIVER TO "MUSCLE" THE STEERING WHEEL THROUGH THE REST OF THE TURN; ALSO STEERING WHEEL DOES NOT RETURN BACK TO STRAIGHT POSITION WITHOUT DRIVER ASSISTANCE. *TR
Apr 09, 2014
FRONT END HAS NO LUBRICATION POINTS AND TENDS TO BIND AND GETS TO A POINT THAT YOU CANNOT TURN THE STEERING WHEEL. *TR
Nov 16, 2009
TIRES
3 complaints
MY VEHICLES PASSENGER SIDE REAR TIRE HAS DEVELOPED A KNOT/BULGE THE SIZE OR A HAND PALM. THE BULGE APPEARS UNDER THE TREAD AND AROUND TO THE SIDEWALK. THE TIRE HAS 18 MONTHS LEFT ON A 36 MONTH PRORATED WARRANTY 16000 MILES SINCE INSTALLED IN 2017. M+S 215/60R17 0225835 35T20 DOT U9KT FYD 9717 SRT TOURING I WILL HAVE TO PAY A $70.00 PRORATE AMOUNT TO GET THE TIRE REPLACED. THE VEHICLE IS A 2006 FORD 500 WITH 176000 MILES. YO DO NOT LIST THE TIRE NAME (SRT TTOURING) ON YOUR LIST FURTHER INTO THE FORM. I HAD TO PICK A NAME TO CONTINUE THE COMPLAINT..
Jun 15, 2019
SEVERE SIDEWALL CRACKING OF CONTINENTAL CT95 TIRES. ISSUE WIDELY REPORTED ONLINE. TIRES AT 60% OF TREAD, 3.5 YEARS SINCE NEW. REMAINDER OF TIRE IS IN VERY GOOD CONDITION. *TR
Oct 21, 2010
PIRELLI P6 (P225/55 R18) TIRE FAILURE ON INTERSTATE 40. THE ENTIRE TREAD AREA & ABOUT 1 INCH OF THE SIDEWALL BROKE AWAY FROM BOTH SIDEWALLS. THE REMAINING TWO SIDEWALLS STAYED ON THE RIM BUT THE TREAD CAME OFF. THE TIRES ARE ORIGINAL TO THE 2006 FORD 500 - WITH 40K MILEAGE. THE OTHER 3 TIRES APPEAR TO BE OK. ALL HAVE BEEN MAINTAINED AND ROTATED EVERY 5K MILES. FORTUNATELY THERE WAS NO WRECK - I WAS EXTREMELY LUCKY CONSIDER THE TRAFFIC SPEED. I RETRIEVED THE TREAD FROM THE ROADSIDE AFTER HAVING THE TIRE REPLACED. *TR
Dec 30, 2008
VEHICLE SPEED CONTROL,ENGINE,FUEL/PROPULSION SYSTEM
3 complaints
THE WRENCH LIGHT CAME ON AND I LOST ALL POWER, NOW IT DOESN'T ACCELERATE AND THE MORE ALSO IS A LOUD NOISE COMING FROM THE ENGINE, IT SOUNDS LIKE IT'S GOUNG TO BLOW UP
Sep 23, 2018
I WOULD BE STOPPED AT A STOP SIGN OR RED LIGHT AND WOULD PUSH ON THE THROTTLE TO ACCELERATE. THE GUY WOULD NOT MOVE AT FIRST THEN WOULD "JUMP" AND ACCELERATE QUICKLY. I NEVER HIT ANYONE BECAUSE I WAS CAREFUL, BUT I TOOK IT INTO A FORD DEALERSHIP TO HAVE THEM DIAGNOSE IT. THEY CLAIMED TO KNOW OF THE PROBLEM BUT WOULD NOT COVER IT UNDER WARRANTY. I PAID OVER $1,000 TO HAVE THEM REPLACE MY "THROTTLE BODY." *TR
Jul 26, 2012
THE CAR HAD BEGUN SURGING HARD BOTH IN REVERSE AND FORWARD. IT HAPPENS WHEN STOPPING AND WHEN FIRST PUTTING IT IN GEAR. I'VE BEEN FORTUNATE TO HAVE NOT HIT ANYTHING YET, BUT I AM FEARFUL THAT IT MIGHT HAPPEN. I'M SEEING A LOT OF OTHER PEOPLE HAVING THE EXACT SAME PROBLEM IN SEVERAL FORUMS AND WEBSITES. I DO NOT UNDERSTAND WHY A RECALL HAS NOT BEEN ISSUED FOR THIS PROBLEM AS IT IS OBVIOUSLY A SERIOUS MANUFACTURER'S DEFECT. *TR
Jul 23, 2012
FUEL SYSTEM, GASOLINE,VEHICLE SPEED CONTROL
3 complaints
WHEN YOU SHIFT FROM DRIVE TO REVERSE OR REVERSE TO DRIVE, THE VEHICLE LUNGES. AND DOES IT SEVERAL TIMES. FORD IS AWARE BUT WITH ONLY HALF FIX THE THROTTLE PROBLEM, BY CLEANING IT NOT REPLACING IT. I SPOKE TO A COUPLE DEALERS AND THEY BOTH SAID THE SAME THING, "THAT WILL ONLY CLEAN THE AFFECTED PART AND THAT 65 PER CENT END UP COMING BACK AND THE CUSTOMER ENDS UP PAYING TO $800.00 TO $900.00 TO REPLACE THE PART. THAT FORD WILL NOT REPLACE THE PART EVEN THOUGH IT IS A RECALL PART". NO CRASH YET. HAVE TO BE SURE TO KEEP FOOT ON BRAKE AND KEEP PLENTY OF DISTANCE FROM OTHER VEHICLES / OBJECTS. UPDATED 09/19/13*LJ
Aug 28, 2013
WHEN GOING SLOW LIKE PULLING INTO AND OUT OF A PARKING SPACE OR GOING THROUGH SCHOOL LINE, CAR WILL "SURGE" OR LUNGE UNEXPECTEDLY. VERY UNSAFE FOR THE PEOPLE AND VEHICLES NEARBY. *TR
Sep 06, 2011
CAR LUNGES WHEN COMING TO A STOP OR BACKING. TOOK CAR IN FOR AN OIL CHANGE AND BRAKE JOB. WHEN I PICKED MY CAR UP, IT WAS RUNNING ROUGH SOMETIMES STALLING WHEN LETTING OFF THE ACCELERATOR. IN ADDITION TO SPONTANEOUSLY LURCHING FORWARD, THE ENGINE WILL RACE WHEN PUT INTO PARK. I HAVE COME CLOSE TO HITTING OTHER CARS, PARKING GARAGE WALLS, ETC DUE TO THIS PROBLEM. MY DEALERSHIP NOW IS TELLING ME THE THROTTLE BODY IS NOT WITHIN THE PROPER PARAMETERS AND NEEDS REPLACEMENT. AFTER SOME RESEARCH THIS SEEMS TO BE A COMMON PROBLEM. *TR
May 17, 2011
ENGINE AND ENGINE COOLING,VEHICLE SPEED CONTROL
3 complaints
2006 FORD FIVE HUNDRED. CONSUMER WRITES IN REGARDS TO ENGINE IDLE RPM SURGES AND UNSATISFACTORY SERVICE AT DEALERSHIP. *SMD THE CONSUMER STATED THE SURGING HAPPENED INTERMITTENTLY. THE DEALER WAS UNABLE TO PERFORM ANY REPAIRS, AS THE VEHICLE DID NOT EXHIBIT THE PROBLEM WHILE THE VEHICLE WAS IN THEIR POSSESSION. UPDATED 02/22/13. *JB UPDATED 03/14/13. *JB
Jan 17, 2013
TL*THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. WHEN THE CONTACT ATTEMPTED TO STOP THE VEHICLE IT BEGAN TO LUNGE FORWARD. EXTREME PRESSURE WAS APPLIED TO THE BRAKE PEDAL IN ORDER TO KEEP THE VEHICLE FROM SURGING FORWARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE MOTOR MOUNTS AND THROTTLE BODY NEEDED TO BE REPLACED. AN AUTHORIZED DEALER INFORMED HER THAT THIS WAS VERY COMMON FAILURE AMONG HER YEAR, MAKE AND MODEL VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 69,000 AND THE CURRENT MILEAGE WAS 74,000. UPDATED 11/05/10. *LJ
Aug 12, 2010
TL*THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. ON JUNE 21, 2009, THE CONTACT DEPRESSED THE BRAKE PEDAL, BUT THE VEHICLE LUNGED FORWARD. THE VEHICLE WAS TAKEN TO THE DEALER THE FOLLOWING DAY. THE CONTACT WAS INFORMED THAT THE AIR FLOW SENSOR, TP SENSOR, AND THROTTLE BODY WERE THE REASONS FOR THE FAILURE. THE VEHICLE'S WARRANTY ONLY COVERED THE AIR FLOW SENSOR. THE CONTACT FEELS THAT THE OTHER TWO COMPONENTS SHOULD ALSO BE COVERED AND THAT THIS WAS A SAFETY DEFECT THAT NEEDS CORRECTING. THE FAILURE MILEAGE WAS 49,647.
Jul 08, 2009
AIR BAGS
3 complaints
AIR BAG SYSTEM FAILED , WAS TOLD BY DEALER NONE OF THE AIR BAG IN THE AUTO WILL WORK WITH THE PASSENGERS AIR BAG DEFECTIVE.. WE REPLACED THE SEAT BUT THAT ONE ALSO DIDN'T WORK SO THIS PROBLEM IS NOT LIMITED TO OUR AUTO. WE HAVE HIGH MILEAGE BECAUSE MY WIFE DRIVES 600 MILES A WEEK TO GO TO WORK {ALONE} NO ONE HAS EVER EVEN SAT IN THIS SEAT THIS IS THE PASSENGERS SEAT AIR BAG THAT IS DISABLING THE SYSTEM. I HAVE CONTACTED FORD AND THEY DON'T CARE. *TR
Dec 28, 2012
CRASHED INTO TELEPHONE POLE TRYING TO MISS A CAT AND BROKE POLE IN HALF ON MOTHER'S DAY (5/11). NONE OF THE SIX AIR BAGS IN MY 2006 FORD 500 DEPLOYED. SPOKE TO MANUFACTURER THEY SAID SINCE I SPOKE TO MY INSURANCE COMPANY FIRST THEY COULD NOT DO ANYTHING TO HELP ME. THE INSURANCE COMPANY HAS NOTHING TO DO WITH THE AIR BAGS IN MY VEHICLE NOT WORKING. I FEEL THIS IS A MALFUNCTION AND FORD SHOULD BE RESPONSIBLE FOR THIS. I BOUGHT THIS CAR BECAUSE OF THE SAFETY FEATURES DUE TO HAVING TWO SMALL CHILDREN. THE BODY MAN WHO LOOKED AT THE CAR SAID IT WAS CLOSE ENOUGH TO THE SENSORS THE BAGS SHOULD HAVE WORKED. MY INSURANCE COMPANY ADVISED ME TO TALK WITH THE MANUFACTURER ABOUT THIS PROBLEM. *TR
May 30, 2008
DT*: THE CONTACT STATED WHILE TRAVELING 55 MPH WITH THE CRUISE CONTROL ENGAGED, THE VEHICLE DROVE OFF THE ROAD AND INTO AN EMBANKMENT OF A CREEK FLIPPING THE VEHICLE ONTO ITS ROOF. THE FRONT AIRBAGS FAILED TO DEPLOY ALTHOUGH THE SIDE CURTAIN AIR BAGS DEPLOYED AND THE SEAT BELT WAS WORN. A FENCE POST WAS DAMAGED IN THE ACCIDENT. THE CONTACT WAS TAKEN TO THE HOSPITAL AND TREATED FOR BUMPS AND BRUISES TO THE BODY AND HEAD. A POLICE REPORT WAS TAKEN. THE VEHICLE WAS TOWED TO AN IMPOUND AND THE MANUFACTURER WAS NOTIFIED.
Oct 05, 2006
ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,ENGINE
3 complaints
THE CAR LUNGES FORWARD OR BACKWARDS WHEN SHIFTING GEARS ALSO LUNGES WHEN COMING TO A STOP VERY VIOLENTLY. I DRIVE WITH PLENTY OF SPACE IN FONT OF ME SO I HAVEN'T HIT ANYTHING I'M SURPRISED NO ONE ELSE HAS EITHER. *TR
Sep 08, 2012
WHILE DRIVING THE CAR RPM GAUGE WAS MOVING UPWARD EVEN THOUGH I WAS STILL AT STEADY SPEED. WHEN I SLOWED AND STOPPED IT APPEARED TO CONTINUE TO LUNGE FORWARD. I WAS ABLE TO CONTROL SINCE I HAD SOME DISTANCE FROM THE VEHICLE IN FRONT OF ME. BY THE TIME I REACHED MY DESTINATION I WAS AFRAID THAT IT HAD A MIND OF ITS OWN. IT SETTLED WHEN I TRIED TO PARK FOR IT THEN CUT OFF. THERE HAVE BEEN NUMEROUS EVENTS WHEN THE CAR LUNGED FORWARD OR CUT OFF WHILE DRIVING AND EVEN WHEN I PUT THE CAR IN REVERSE. I HAD THREE (3) MOTOR MOUNTS REPLACED AND NEW BATTERY ALONG WITH THE SAFETY SENSOR. IT COSTS MORE TO REPAIR THAN GENERAL MAINTENANCE. I SEE WHY THEY STOPPED MAKING THIS CAR. ITS DANGEROUS! I AM NOW IN THE PROCESS OF GETTING THE THROTTLE BODY REPLACED WHICH MAY NOT BE UNDER WARRANTY. THIS CAR SHOULD BE RECALLED OR WE SHOULD BE COMPENSATED FOR REPAIRS RELATED TO THIS PROBLEM. *TR
Aug 02, 2012
I HAVE A 2006 FORD FIVE HUNDRED. I PURCHASED IT USED IN JAN 2012. MY CAR CONTINUALLY LURCHES FORWARD WHILE SITTING STILL. THE AIR CONDITIONER WILL NOT COOL WHILE IDLING IF IT IS HOT OUTSIDE. I HAVE ALSO HAD ISSUES WITH LOSING ALL POWER WHILE DRIVING DOWN THE FREEWAY. I WILL BE DRIVING AND ALL GAUGES WILL BOTTOM OUT AND THEN REV UP TO THE HIGHEST. MY RPMS WILL DROP DOWN, THE GAS GAUGE WILL GO TO EMPTY AND AT NIGHT ALL ELECTRICAL LIGHTS AND DASHBOARD NOTIFICATIONS WILL LIGHT UP AND THEN GO OFF. I CANNOT USE THE AIR CONDITIONER, RADIO OR ANYTHING ELSE WHEN THIS HAPPENS. THIS IS VERY DANGEROUS AND I BELIEVE FORD SHOULD BE HELD ACCOUNTABLE FOR NOT FIXING THIS ISSUE SOONER! SOMEONE IS GOING TO GET INTO A FATAL ACCIDENT BECAUSE OF THIS ISSUE!!! LOSING ALL POWER AND SPEED AND THEN HAVING THE VEHICLE LURCH FORWARD IS DANGEROUS! #SCAREDMOMOF3BABIES! *TR
Jul 31, 2012
FUEL SYSTEM, OTHER
3 complaints
I WAS DRIVING DOWN THE FREEWAY AND MY CAR JUST STOPPED THE SECOND TIME I WAS DRIVING DOWN THE STREET AND THE CAR STOP THE SPEED LIMIT WAS 50 I WAS TURNING ONTO STATE HWY 6 AND THE CAR DIED I ALMOST GOT HIT THESE PROBLEM HAPPENED FOR QUITE SOME TIME AND VERY OFTEN I CALLED FORD AND THEY SAID THERE WAS NOTHING THEY COULD DO BECAUSE THERE WAS NO RECALL AFTER SEARCHING ONLINE I FOUND OUT HUNDREDS OF PEOPLE WERE HAVING THE SAME PROBLEM WITH THE FORD FIVE HUNDREDS AND FREESTYLE'S. *TR
Jul 24, 2011
PURCHASED A 2006 FORD FIVE HUNDRED AND NOTICED THAT WHEN I WOULD PUT THE CAR IN DRIVE OR REVERSE IT WOULD LURCH FORWARD OR BACKWARD QUITE EXCESSIVELY. CALLED THE DEALER AND TOOK THE CAR IN AND WAS TOLD THAT THE THROTTLE BODY MIGHT BE GUMMED UP AND THAT THE BATTERY ALSO FAILED AND COULD CAUSE THAT PROBLEM DUE TO RESETTING EVERYTIME THE CAR STARTS. THEY CLEANED THE THROTTLE BODY PLATES AND REPLACED THE BATTERY AND THAT SAME NIGHT THE VEHICLE DID THE SAME THING WHEN I PUT THE CAR IN REVERSE. *TR
Mar 11, 2011
FORD NEEDS TO HAVE A RECALL REGARDING THE FIVE HUNDREDS LUNGING WHEN PUT IN REVERSE AND SOMETIMES WHEN PUT INTO DRIVE. MINE STARTED THIS ABOUT A YEAR AGO AND I DON'T HAVE TO PUT MY FOOT ON THE GAS TO GO IN REVERSE. EVEN WHEN PARKED DOWNHILL! MY HUSBAND AND I KNOW YOU MUST KEEP YOUR FOOT ON THE BRAKE ANYTIME YOU TAKE THE CAR OUT OF GEAR. IT'S VERY SCARY AND WE WILL NOT LET ANYONE DRIVE THE CAR FOR FEAR OF AN ACCIDENT. PLEASE LOOK INTO THIS! *TR
Aug 17, 2010
FUEL SYSTEM, GASOLINE,POWER TRAIN
3 complaints
ADDENDUM TO ODI ID NUMBER : 10386714 THE FUEL PUMP, FUEL FILTER HAD TO BE REPLACED, AND THE INJECTORS FLUSHED - COST $800 ++. DEALER NOW STATES CODES SHOW PCM NEEDS TO BE REPLACED. REPAIR COVERED UNDER FEDERAL EMISSIONS WARRANTY (8 YEARS OR 80,000 MILES) DUE TO MY CURRENT MILEAGE BEING 79,008 MILES. DEALER COVERED CAR RENTAL UNTIL PART ARRIVES AND IS INSTALLED. I HAVE A "BUCKING" BEHAVIOR, AFTER TRAVELING APPROXIMATELY 2 HRS AT SPEEDS OVER 60MPH (INTERSTATE TRAVEL). THE CAR WOULD LURCH SEVERELY AND HESITATE, THE ENGINE REVVED VERY LOUDLY, AND THE SPEED REDUCED TO 40 MPH, EVEN THOUGH I HAD MY FOOT TO THE FLOOR ON THE GAS PEDAL. AFTER DRIVING OFF THE HIGHWAY, IT WOULD DO THE SAME THING AT CITY SPEEDS AND HAD LITTLE TO NO ACCELERATION. DEALER SAID THE CODES SHOWED IT WAS THE FUEL PUMP AND IT WOULD DO THE BUCKING AND LACK OF ACCELERATION AFTER THE PUMP HEATED UP. DEALER SAID THE CAR WAS UNSAFE TO DRIVE. THE FUEL PUMP, FUEL FILTER HAD TO BE REPLACED, AND THE INJECTORS FLUSHED. *TR
Mar 09, 2011
CAR SURGES FORWARD/BACKWARD WHEN ENGAGED IN GEAR FROM DEAD STOP AND BRAKE IS RELEASED WITHOUT HAVING EVEN TOUCHED THE ACCELERATOR. SEEMS TO BE WORSE WHEN HEATING/COOLING FAN IS ON, ESPECIALLY ON RECIRCULATE, AND RPMS WILL SURGE/RACE AT DEAD STOP WITH BRAKE FIRMLY APPLIED WHEN THE STEERING WHEEL IS TURNED TO EITHER SIDE. PROBLEM IS ESPECIALLY NOTICEABLE IN PARKING LOTS OR ANYWHERE IN LOW SPEED STOP/GO DRIVING CONDITIONS. CONCERNED FOR PEDESTRIAN SAFETY AS I HAVE HAD THE CAR JUMP UNEXPECTEDLY AND NEARLY HIT THEM. CHECK ENGINE LIGHT CAME ON A COUPLE OF WEEKS AGO AND CAR WENT INTO LIMP HOME MODE INDICATING ERROR CODES P061B & P2016 WHICH MEANS THE THROTTLE BODY NEEDS TO BE REPLACED AFTER DRIVING IN DEEP SNOW, EXTREMELY COLD TEMPERATURE AFTER CAR HAD BEEN SITTING FOR 3 DAYS, THE CHECK ENGINE LIGHT HAS CLEARED BUT THE CAR CONTINUES TO HAVE THE SURGING ISSUES THOUGH IT DOES SEEM WORSE IN WARMER WEATHER THAN COLD. SO FAR I HAVE NOT REPLACED THE THROTTLE BODY THOUGH I INTEND TO AS SOON AS I CAN GET AHOLD OF THE PART. *TR
Dec 20, 2010
WHEN YOU SHIFT OUT OF PARK INTO EITHER REVERSE OR DRIVE THE CAR SURGES FORWARD VERY QUICKLY. IF YOU DON'T HOLD THE BRAKE TO THE FLOOR YOU CAN'T STOP IT. THIS IS VERY DANGEROUS! WHEN UNLOADING MY CHILDREN AT SCHOOL I ALMOST RAN OVER A CHILD DUE TO THIS DEFECT. WHEN I LOOKED ONLINE I FOUND THOUSANDS OF COMPLAINTS ABOUT THIS SAME ISSUE. FORD WON'T RECALL IT AND THE PARTS (THROTTLE BODY ASSEMBLY $800) ARE ON A 2 MONTH BACK ORDER! *TR
Sep 11, 2010
EXTERIOR LIGHTING
3 complaints
DRIVER AND PASSENGER SIDE LOW BEAM BULB HOLDER/MOUNTS/SOCKET, MELTED- DEFORMED. *TR
May 15, 2009
LEFT HEADLAMP (RUNNING LAMP) IS NOT WORKING. WENT TO CHANGE THE BULB AND FOUND THE END OF THE HARNESS IS MELTED. LOOKS LIKE A POSSIBLE FIRE HAZARD. WILL TAKE TO DEALER ASAP FOR REPAIR. *TR
Mar 25, 2008
AUTO HEADLIGHTS FAIL DURING OPERATION, DRIVING IN RURAL NON LIGHT SENSITIVE AREAS. *NM
Mar 31, 2006
VISIBILITY
3 complaints
POWER DRIVERS WINDOW INTERMITTENTLY MALFUNCTIONS, WHEN WINDOW IS PART WAY DOWN AND PUSH BUTTON TO GO UP THE WINDOW GOES DOWN INSTEAD OF UP, WHEN IT REACHES 3/4 OF THE WAY DOWN IT STOPS ON ITS OWN, THEN YOU PUSH THE UP BUTTON AGAIN AND IT DOES NOTHING, THEN YOU PUSH THE UP BOTTOM AGAIN AND IT FINALLY GOES UP. *TR
May 05, 2009
DT*: THE CONTACT STATED WHILE DRIVING DURING SUMMER THERE IS A REFLECTION OFF OF THE WINDSHIELD CAUSING DIFFICULTY IN VISIBILITY
Jul 07, 2006
MY 2006 FORD 500 ELECTRIC WINDOW REGULATOR GOES DOWN WHEN PULLING UP ON THE WINDOW CONTROL UNLESS YOU WAIT 5 SECONDS AFTER LOWERING THE WINDOW. THIS IS NOT ACCEPTABLE SINCE THE WINDOW UP OR DOWN BUTTON CONTROLS SHOULD DO WHAT ARE MEANT TO DO - NOT THE OPPOSITE. *JB
Jan 31, 2006
SERVICE BRAKES
2 complaints
THE BRAKES ARE SPONGY. VERY SELDOM THEY WILL BE NORMAL. MOST OF THE TIME THEY WILL BE SOFT AND HAVE TO BE PUMPED. SOMETIMES THE BRAKES WILL BE FIRM FOR A COUPLE OF SECONDS AND THEN THE PEDAL WILL SINK TO THE FLOORBOARDS. THIS OCCURS DURING DURING NORMAL DRIVING AND STOPPING AND ALSO OCCURS WHEN VEHICLE IS IN PARKED. BRAKES HAVE BEEN PROFESSIONALLY SERVICED INCLUDING HOOKED TO A COMPUTER FOR PROPER BLEEDING. PROBLEM HAS NOT BEEN RESOLVED.
Feb 07, 2020
AS I STARTED MY CAR TO LEAVE, THE PARKING BRAKE WOULD NOT RELEASE RIGHT (WENT DOWN TO THE FLOOR), THE BRAKE LIGHT WAS DISPLAYED ON THE DASH, AND I COULD TELL THE PARKING BRAKES WERE STILL ENGAGED. SINCE THE PARKING BRAKES WERE STILL ENGAGED, MY REAR WHEELS WERE LOCKED UP. MY CAR THEREFORE WAS NOT DRIVABLE. THERE WAS NO PRIOR WARNING OF THIS PROBLEM FOR MY FORD 2006 FIVE HUNDRED. I HAVE NOT BEEN INFORMED OF ANY RECALLS FROM FORD MOTOR COMPANY DUE TO THIS PROBLEM. *TR
Jul 17, 2013
ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM
2 complaints
MY 2006 FORD FIVE HUNDRED IS SURGING THERE'S NO POWER IT STUMBLES SHUTS OFF.
Oct 05, 2019
BEFORE JULY 2010 I BEGAN NOTICING THAT MY ENGINE WOULD RACE UP TO 1500 RPM WHILE IDLING. I WOULD ALWAYS KEEP MY FOOT ON THE BRAKE SO THE CAR WOULD NOT LURCH FORWARD. THEN ON THE 4TH OF JULY MULTIPLE ENGINE ERRORS APPEARED ON THE CAR COMPUTER. THE FORD DEALER DIAGNOSED A THROTTLE BODY MALFUNCTION. AFTER REPLACEMENT NO PROBLEM UNTIL JUNE 2012. ONCE AGAIN THE ENGINE IS RACING TO 2000 RPM WHILE IDLING AT A STOP. I AM SURE THAT THIS PROBLEM IS ONGOING WITH SOME FORD PRODUCTS AND WILL SOME DAY OR HAS CAUSED AN ACCIDENT. IT IS NOT A CONSTANT RPM RATE BUT THE RPM GOES FROM 700 TO 2000. *TR
Jun 30, 2012
FUEL/PROPULSION SYSTEM
2 complaints
ELECTRONIC THROTTLE BODY STOPPPED WORKING. CAR ABRUPTLY LOST ALL POWER IN BUSY TRAFFIC, LUCKY TO BE ALIVE. I WAS DRIVING IN THE LEFT LANE AND ALL OF A SUDDEN ALL POWER WAS GONE AND THE CAR WOULDN'T GO! I HAD IT DIAGNOSED BY AAA REPAIR SHOP IN LOS ANGELES. HAVE TO PAY 900 TO GET NEW THROTTLE BODY UNIT.
Jul 01, 2018
WRENCH LIGHT CAME ON AND IT FEELS LIKE YOU LOSE POWER MOMENTARILY. WHEN IT KICKS BACK IN, IT LUNGES AND WILL ALMOST GIVE YOU WHIPLASH. THIS HAPPENS SPORADICALLY DURING ACCELERATION USUALLY ON A HIGHWAY.
Nov 09, 2016
POWER TRAIN,ELECTRONIC STABILITY CONTROL (ESC),ENGINE
2 complaints
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
Jun 02, 2016
I WAS APPROACHING A RED LIGHT AND AS I LIFTED MY FOOT OFF THE BRAKE PEDAL..............THE CAR ACCELERATED ABRUPTLY AND I WAS UNABLE TO STOP CAUSING ME TO PASS RED LIGHT, ALMOST STRIKING AN ONCOMING VEHICLE THAT WAS MAKING A LEFT HAND TURN AND DRIVING ONTO SIDEWALK. FORTUNATELY NO ONE WAS HURT AND AN ACCIDENT WAS AVOIDED DUE TO MY QUICK RESPONSE. THE VEHICLE HAS ACCELERATED ABRUPTLY ON SEVERAL OTHER OCCASIONS. I WAS PARKED IN A PUBLICS PARKING LOT WHEN I PUT MY VEHICLE IN REVERSE THE VEHICLE ONCE AGAIN ACCELERATED ALMOST HITTING PARKED VEHICLE BEHIND ME. I WAS ADVISED THE THROTTLE SENSOR WAS DEFECTIVE ON 2005 & 2006 FORD FIVE HUNDRED MODELS AND NO RECALL YET! THIS DEFECT CAUSES VEHICLE TO ACCELERATE ABRUPTLY (EVEN WHEN PARKED) OR NOT ACCELERATE AT ALL! THERE HAVE BEEN MANY REPORTS REGARDING THIS ISSUE AND NOTHING HAS BEEN DONE ABOUT IT. WHEN A LIFE IS LOST OR SOMEONE IS SEVERELY INJURED..................IS THAT WHEN SOME ACTION WILL BE TAKEN? ACCORDING TO REPORTS EVEN IF THE PART GETS REPLACED IT DOES NOT GUARANTEE IT WILL NOT GO BAD AGAIN. REPAIRS HAVE BEEN KNOWN TO COST BETWEEN $450.00 TO $750.00. *TR
Jun 11, 2012
ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL
2 complaints
WHEN I FIRST START MY CAR ITS SLOW TO GIVE POWER, OFTEN WHEN I DRIVE IT ON THE STREET IT'LL JUST LOSE COMPLETE POWER AND DIE DOWN. THEN I HAVE TO RESTART ITFOR IT TO TEMPORARILY GO AWAY THEN IT HAPPENS AGAIN. *TR
Sep 24, 2014
2010 DRIVING ON HIGHWAY IN VIRGINIA, CAR WAS ACCELERATING ON IT'S OWN, IT WAS LIKE THE CAR WAS IN CONTROL AND NOT THE DRIVER. PULLED OVER AND CAR STALLED, ENGINE LIGHT CAME ON. TOOK CAR TO FORD DEALER WAS TOLD THROTTLE CONTROL ASSEMBLY. 52,200 MILES HAD IT REPLACED. CONTACTED FORD OCT 2010. NOVEMBER 2012 FORD ISSUE CUSTOMER SATISFACTION PROGRAM, FINALLY REIMBURSED 2013. JULY 2014, 100,457MILES SAME PROBLEM AGAIN HAD TO AGAIN REPLACE THROTTLE CONTROL SYSTEM. *TR
Aug 25, 2014
ENGINE AND ENGINE COOLING,POWER TRAIN
2 complaints
SINCE 2009 MY FORD 500 HAS HAD ISSUES WITH NO A/C AND SURGING. THEY COULD NOT FIGURE OUT WHAT WAS GOING ON (FORD) AND EVENTUALLY FOUND IT TO SUPPOSEDLY BE THE THROTTLE BODY ASSEMBLY. AFTER THAT WAS "FIXED" THE CAR DID NOT SURGE BUT THE A/C WOULD NOT WORK WHEN THE CAR WAS IDLE IN WARM WEATHER. I'VE TAKEN THE CAR BACK AT LEAST A DOZEN + TIMES WITH THIS ISSUE. NOW THE CAR IS BEGINNING TO SURGE AGAIN TOO... IT HAPPENED TWICE, NOT ALWAYS BUT IT HAPPENS... IT IS QUITE SCARY WHEN THERE IS A CAR IN FRONT OF ME AND I AM AT A TRAFFIC LIGHT OR SIGN AND THE CAR SURGES FORWARD - I HAVE CALLED FORD MOTOR CO NUMEROUS TIMES AND TAKEN IT TO MY FORD DEALER. *TR
Jul 14, 2014
THE VEHICLE WILL STALL AND JERK. THE VEHICLE WILL LUNGE OUT EVEN WHEN THE BRAKE IS PRESSED. IT HAS DONE THIS IN PARKING LOTS AND WHILE DRIVING. THIS IS DANGEROUS AS IT ALMOST CAUSED AN ACCIDENT BY JERKING BACKWARD IMMEDIATELY WHEN I SHIFTED TO REVERSE WHEN I WAS IN THE PARKING LOT- MY FOOT WAS ON THE BRAKE AND THE CAR STILL EXCELLED. *TR
Feb 22, 2012
ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE,VEHICLE SPEED CONTROL
2 complaints
FORD 500 LURCHES SEVERELY AT RANDOM TIMES WHILE THE ENGINE IS ENGAGED. THIS HAPPENS MOST DANGEROUSLY AT HIGH SPEEDS, DUE TO DRIVER'S INABILITY TO CONTROL VEHICLE ADEQUATELY TO DEFEND AGAINST POTENTIAL CRASHES OR CONTROL SPEED DURING TURNS. THIS HAS CAUSED PROBLEMS ON THE SNOW AND ICE HERE IN ALASKA BECAUSE UNCONTROLLED ACCELERATION REDUCES TRACTION. ALSO OCCURS AT LOW SPEEDS, WHICH IS MORE EASILY CONTROLLED THROUGH BRAKING, BUT REQUIRES EXTREME CAUTION IF ENGAGING VEHICLE WHEN PEDESTRIANS OR OTHER VEHICLES ARE NEAR. IT HAS SURPRISED AND SCARED ME ON MANY OCCASIONS SINCE I FIRST PURCHASED THIS CAR A MONTH AGO, BUT THE REASON I AM WRITING THIS IS BECAUSE I HAD A SCARY INCIDENT TODAY WHEN PULLING OUT OF A GROCERY STORE PARKING LOT (PEDESTRIANS IN FRONT OF ME WHEN IT SUDDENLY JUMPED AS SOON AS ENGINE ENGAGED). TOOK IT TO THE MECHANIC AND DIAGNOSTIC CHECK SAYS ISSUES WITH FUEL DELIVERY SYSTEM. THE MECHANIC STATED THAT AFTER RESEARCHING THE ISSUE THIS IS A VERY COMMON PROBLEM FOR THIS MODEL AND THAT IT IS MOST LIKELY THE THROTTLE BODY, AND SAYS THE CAR SHOULD NOT BE DRIVEN IN ITS CONDITION. IT IS ONE OF THE SCARIEST ISSUES I'VE EVER HAD TO DEAL WITH. AFTER READING MORE ABOUT IT ON THE INTERNET THIS EVENING IT SEEMS THAT THIS ISSUE IS VERY COMMON AND HUNDREDS OF PEOPLE HAVE HAD SIMILAR SCARY INCIDENTS WITH THIS CAR THAT THEY HAVE REPORTED ONLINE. IF THIS MANY PEOPLE ARE WRITING ABOUT IT ONLINE, PRESUMABLY THERE ARE THOUSANDS MORE WHO ARE HAVING THE SAME PROBLEM AND DO NOT HAVE THE RESOURCES OR KNOW HOW TO REPORT THE ISSUE. *TR
Nov 09, 2011
5/20-7/18/11 CAR ACCELERATED QUICKLY AND LURCHED BACKWARD WITH BRAKE ON WHILE BACKING OUT OF PARKING SPACE; WRENCH LIGHT CAME ON. ERROR CODES WERE FOR ALTERNATIVE FUEL CONTROL MODULE AND THROTTLE ACTUATOR CONTROL SYSTEM. SOMETIMES CAR LURCHED FORWARD WHILE BRAKING, ENGINE REVVED, CAR SHUDDERED, AND WRENCH AND/OR CHECK ENGINE LIGHT CAME ON. STARTED HAPPENING ALMOST DAILY. VERY SCARY AND UNPREDICTABLE. MASS AIR FLOW SENSOR AND EGR VALVE WERE REPLACED. HAD SAME ISSUES 2 DAYS LATER. THROTTLE BODY AND VACUUM HOSES WERE REPLACED. CONTACTED FORD AND THEY REFUSED TO COVER PARTS AND LABOR BECAUSE CAR WAS NO LONGER UNDER WARRANTY. LAST REPAIR WAS DONE 30 DAYS AGO AND I'VE HAD NO MORE PROBLEMS, BUT IT COST ME $1600 TO REPAIR.
Aug 27, 2011
FUEL SYSTEM, OTHER,POWER TRAIN
2 complaints
MY 2006 FORD FIVE HUNDRED ACCELERATES UNCONTROLLABLY. WHEN THE CAR IS SHIFTED INTO GEAR IT ACCELERATES WITHOUT THROTTLING. IT HAPPENS FROM PARK-TO-ANY GEAR AND SOMETIMES WHEN AT TRAFFIC STOPS. I'VE NOTICED THIS PROBLEM FOR A WHILE, BUT IT IS GETTING PROGRESSIVELY WORSE. SCARY!!! *TR
Jul 30, 2011
MY 2006 FORD 500 LUNGES INTERMITTENTLY WHEN SHIFTING FROM PARK TO DRIVE OR REVERSE. THE CAR WAS TAKEN TO A REPAIR SHOP WHO COULD NOT REPRODUCE THE LUNGING AND SAID NOTHING APPEARED WRONG. SINCE IT ONLY OCCURS INTERMITTENTLY, IT IS DIFFICULT TO EVEN GET IT FIXED. IT APPEARS MANY OTHER FORD 500'S ARE HAVING THE SAME PROBLEM. *TR
Jul 28, 2010
WHEELS
2 complaints
2006 FORD FIVE HUNDRED TIRE BLEW OUT CAUSING CONSUMER TO LOOSE CONTROL AND OVERTURN THE VEHICLE. *KB * THE CONSUMER STATED SHE FELT A VIBRATION PRIOR TO THE ACCIDENT. *JB THE CONSUMER STATED IT DID NOT APPEAR THAT THE INCIDENT WAS DUE TO A TIRE FAILURE. POSSIBLY THE LUG NUTS AND WHEEL WERE THE CAUSE. UPDATED 09/24/06. *JB
Aug 22, 2006
DT*: THE CONTACT STATED ON 7-29-06 WHILE DRIVING ON THE INTERSTATE AT 70 MPH, THE TIRE, RIM AND A PORTION OF THE WHEEL HAD SEPARATED FROM THE WHEEL BUT WAS STILL ATTACHED. THE INCIDENT RESULTED IN THE CONTACT LOSING CONTROL OF THE VEHICLE AND CAUSED AN ACCIDENT, BUT NO ONE WAS INJURED. PRIOR TO THE INCIDENT, THE VEHICLE DRIFTED TO THE LEFT RAPIDLY. BOTH SEAT BELTS WERE IN USE AT THE TIME. THE MANUFACTURER WAS CONTACTED AND DECLINED TO INSPECT THE VEHICLE BECAUSE THERE WAS NO PRIOR HISTORY OF THIS TYPE OF PROBLEM. THE VEHICLE WAS TOTALED AND A POLICE REPORT WAS TAKEN. *AK
Aug 07, 2006
POWER TRAIN,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL
1 complaint
I WAS ON MY WAY HOME COMING DOWN FARROW RD. AND MY CAR STALLED OUT, SO I SLOWLY PULLED IN THE MEDIAN TURN CAR OFF AND BACK ON. WHEN I GOT READY TO PULL OUT OF THE MEDIAN THE CAR WOULDN'T GO NO FASTER THAN 5 MILES AND HOUR. SO I HAD MY FRIEND HELP ME PULL IT OUT OF THE ROAD AND TAKE ME HOME AND TOW MY CAR TO THE HOUSE. WHEN I GOT IT HOME THERE WASN'T ANY ACCELERATION, RPMS WONT MOVE AT ALL, CAR HAS POWER AND CRANKS BUT WHEN I PUT IT IN DRIVE IT WON'T GO ANYWHERE. IT STALLS AND CUTS OFF, EVEN IN NEUTRAL NO ACCELERATION. EVERYTHING LIGHTS UP AND CUTS ON BUT NO ACCELERATION. FROM MY PHOTOS BELOW YOU WILL SEE I HAVE REPLACED ALTERNATOR, THROTTLEBODY, THE RED AND BLACK WIRING ON THE BACK OF THE INTAKE I'VE CHECKED ALL MY HOSES THERE WAS NO SPLITS NO CUTS NO VACUUM LEAK AND EVERY TIME I GET A READING ON IT IT GIVES ME A DIFFERENT CODE PLEASE READ AND REPLY IF THIS IS A RECALL I NEED MY CAR FIXED IMMEDIATELY
Jan 18, 2021
ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM
1 complaint
BATTERY JUST GOES DEAD OVER NIGHT. SIGNAL LIGHTS MELTED AND QUIT WORKING. CLUSTER PANEL JUST SHUTS OFF WHILE RUNNING AND CAN'T USE AIR, RADIO, WINDOWS, LOCKS, SEATS, ETC. CAR SHUTS OFF WHILE DRIVING DOWN THE ROAD. HAVE REPLACED ALL PARTS SUGGESTED BY CODES. STILL NO FIX. WONT SHIFT FROM FIRST GEAR AFTER CLUSTER PANEL SHUTS OFF. THERE ARE HUNDREDS OTHER COMPLAINTS. THIS IS DANGEROUS AND SHOULD BE AN ELECTRICAL RECALL. HAPPENS RUNNING DRIVING AND SITTING STILL.
Oct 21, 2020
POWER TRAIN,FUEL/PROPULSION SYSTEM
1 complaint
THE INTAKE MANIFOLD IS MELTING ON THE INSIDE CAUSING MELTING PLASTIC TO DRIP INTO THE THROTTLE BODY,CAUSING THE CAR TO RUN VERY POORLY ARE NOT AT ALL!!!
Sep 21, 2020
STEERING,STRUCTURE,ENGINE
1 complaint
GOT INTO AN ACCIDENT AND RIGHT MIRROR WAS FULLY BROKEN. RIGHT SIDE OF THE BODY WAS ALSO SMASHED IN. LEFT BRAKE LIGHTS STOPPED WORKING AND ENGINE MAKES WEIRD SOUNDS.
Sep 13, 2020
ELECTRONIC STABILITY CONTROL (ESC),ENGINE
1 complaint
THE CAR IS SURGING AND FEELS LIKE IT IS ABOUT TO FALL APART THE CAR HAS LOW MILES AND THE ENGINE FEELS LIKE THE TRANSMISSION IS SLIPPING BUT WAS TOLD THAT THIS IS A COMMON PROBLEM WITH THE FORD 500 I SEE THERE IS A EXTENDED WARRANTY BUT I JUST RECENTLY PURCHASED THIS CAR AND SEEMS LIKE THE WARRANTY EXPIRED AND I SEE FORD IS AWARE OF THIS AND REFUSES TO FIX THIS ISSUE WHICH IS A HAZARDOUS CONDITION AND I FEEL LIKE THAT IM GOING TO HAVE TO GET A LAWYER TO GET ANYTHING DONE BECAUSE FORD IS REFUSING TO FIX THIS ISSUE WITH THESE CARS AND ITS VERY DANGEROUS DRIVING THE CAR MAKES A LOUD KNOCK AND THE ENGINE DROPS BACK IN AND ITS BREAKING THE MOTOR MOUNTS
Aug 29, 2020
VEHICLE SPEED CONTROL,SERVICE BRAKES,ENGINE
1 complaint
WHILE STOPING AT RED LIGHT CAR STALLS BUCKLES DOSE NOT GO OVER 50 MPH AS IT HITS 50 MPH RPMS GO TO6000 SPEED STAYS ON 50 MPH AND I CAN'T GO ON A HIGH WAY CAUSE I CAN'T KEEP UP WITH TRAFFIC NOISE COMING FROM MOTER CAR GOT HOT GOING UP HILLS IN 80 DEGREE WEATHER AND IT JUST ALL AROUND RUNS LIKE [XXX]. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Aug 17, 2019
SERVICE BRAKES,ENGINE
1 complaint
WHEN CAR IS ON, WHEN TAKING FOOT OFF OF BRAKE OR REVERSING, CAR SURGES OR JUMPS FORWARD WITHOUT WARNING. I HAVE ALMOST BEEN IN SEVERAL ACCIDENTS BECAUSE OF THIS PROBLEM.
Aug 16, 2019
ELECTRICAL SYSTEM,EXTERIOR LIGHTING,FUEL/PROPULSION SYSTEM
1 complaint
DOOR FROZE SHUT AND EVER SINCE MANUALLY OPENING THE MESSAGE CENTER STATES DRIVER DOOR AJAR AND PASSENGER DOOR AJAR AND THEY ARE NOT. BUT I CAN'T RESET DRIVER CONTROLS UNTIL DOORS SHOW CLOSED. HAVE RUN CODE IN MY CAR AND ONLY CODE IS P0193 FUEL RAIL PRESSURE SENSOR. NO CODES FOR DOORS.
Jul 23, 2019
POWER TRAIN,EXTERIOR LIGHTING
1 complaint
HARD KNOCKING IN TRANSMISSION DURING NORMAL OPERATION. INTERIOR LIGHTS COME ON WHILE USING VEHICLE AND WON'T GO OFF
Mar 03, 2019
STEERING,ELECTRICAL SYSTEM,UNKNOWN OR OTHER
1 complaint
INSTRUMENT PANEL SHUTS OFF INTERMITTENTLY. DAYS LIGHTS FLICKER.
Feb 02, 2019
ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE
1 complaint
CAR WILL BE DRIVEING 55 AND COMPLETELY SHUT OFF. LOSSING EVERYTHING INCLUDING POWERSTEARING. HAVE TO PUT IN NEUTRAL N COAST TO SIDE OF THE ROAD, SOMETIMES WILL RESTART, OTHERS IT WONT. ALSO WILL START BUCKING AND SHUT OFF. I CAN BE DOING 10MPH N GO TO TURN A CORNER N IT SHUTS OFF. CAN SEEM TO RUN FINE, BE IN THE MIDDLE OF AN INTERSECTION AND THE CAR SHUT OFF AND WOULDNT RESTAR GOOD THING I CAN DRIVE AND KNEW WHAT TO DO OR I WOULD HAVE CRASHED NUMEROUS TIMES. HAVE CHANGED THE THROTTLE BODY AND ACCELERATOR, N BOTH SENSORS. DID NOT FIX PROBLEM. NOW SAYING IT'S THE PCM SHUTTING THE CAR OFF.
Jan 23, 2019
ELECTRICAL SYSTEM,EXTERIOR LIGHTING,UNKNOWN OR OTHER
1 complaint
PULLED IN DROP OFF A DONATION AT A SECOND HAND STORE. I PUT IT IN PARK AND TURNED OFF THE VEHICLE; OPENED THE TRUNK; AND LOOKED UP STARTLED WHEN A GUY SITTING NEARBY SAID THAT MY CAR WAS SMOKING AND ON FIRE (ABOUT 10 SECONDS SINCE I SWITCHED THE CAR OFF AND GOT OUT). HE WAS ON THE RIGHT, SO I MOVED AROUND THE CAR TO THE RIGHT LOOKING TOWARDS THE ENGINE. AN EMPLOYEE OF THE STORE THAT WAS ON THE BACK, LEFT SIDE OF THE CAR POINTED TOWARDS AND SAID, 'LOOK! YOUR SIDE MIRROR IS ON FIRE!' I THEN SAW THE SMOKE BILLOWING TO THE LEFT (A STRONG AFTERNOON BREEZE WAS BLOWING NORTH). I CAME AROUND AND PEERED IN BEHIND THE ACTUAL 'MIRROR' PART; THE FIRE HAD JUST GONE OUT. LOOKING AT IT, I COULD SEE IT WAS THE SECURITY LIGHT ON THE BOTTOM SIDE OF THE MIRROR; IT WAS COMPLETELY MELTED AND FUSED TO THE MIRROR HOUSING- A BUBBLY MESS OF PLASTIC. IT SMELLED OF ACRID, MELTED PLASTIC AND BURNED ELECTRONICS. THE UNDERSIDE OF THE MIRROR HAD CAUGHT FIRE AND STARTED BURNING FOR A BIT BEFORE THE FUSE FINALLY BLEW. I AM SO GLAD MY BABY AND KINDERGARTENER WEREN'T IN THE CAR AT THIS TIME! THEY USUALLY ARE. THE LENGTH OF TIME OF TIME IT TOOK FOR THE FUSE TO FINALLY BLOW IS QUITE ALARMING! IT COULD HAVE RESULTED IN THE RAPID SPREAD OF A FIRE THAT WOULD QUICKLY OVERTAKE THE VEHICLE. WHAT IF I WAS AT A GAS STATION WHEN THIS HAPPENED WHEN THEIR HAPPENED TO BE SOME PETROL-VAPOR PRESENT. MY NEXT STOP WAS TO GET TWO PROPANE TANKS FILLED. THEY HAVE TO BLEED OFF A CERTAIN AMOUNT OF PROPANE EACH TIME WHEN FINISHED FILLING A TANK. IT ISN'T FAR FETCHED THAT THIS ELECTRICAL ISSUE WITH FAILED SAFEGUARDS COULD HAVE RESULTED IN FAR MORE INJURY THAN MY SLIGHTLY BURNED FINGERS. THIS NEEDS TO BE INVESTIGATED IMMEDIATELY BEFORE SOMETHING TERRIBLE HAPPENS TO SOMEONE. THIS IS A FANTASTIC CAR! WE LOVE IT. THIS IS PROBABLY AN EASY FIX, BUT IF IT ISN'T FIXED, MUCH WORSE COULD HAPPEN!
Oct 15, 2018
AIR BAGS,STRUCTURE
1 complaint
REAR ENDED AN 18 WHEELER AND TOTALLED THE CAR BUT THE AIR BAGS DID NOT DEPLOY AND IT WAS A VERY BAD ACCIDENT.
Jun 01, 2018
SUSPENSION
1 complaint
TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. WHILE DRIVING 20 MPH, THE REAR OF THE VEHICLE SWAYED ABNORMALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE INNER PIVOT ASSEMBLY ON THE REAR SUSPENSION OF THE VEHICLE WAS SEVERELY CORRODED. THE CONTACT STATED THAT RUST CAUSED THE INNER PIVOT ASSEMBLY TO SEPARATE FROM THE SUBFRAME. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. UPDATED 04/06/17 LJ *CN
Feb 08, 2017
POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE
1 complaint
TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. WHILE DRIVING 60 MPH, THE VEHICLE FAILED TO ACCELERATE AND THE POWER TRAIN WRENCH ICON ILLUMINATED. THE CONTACT WAS ABLE TO SHUT OFF AND RESTART THE VEHICLE IN ORDER TO OPERATE NORMALLY. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ELECTRONIC THROTTLE BODY SENSOR FAILED, SENDING THE VEHICLE INTO "LIMP MODE", AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE PERSISTED ON SEVERAL OCCASIONS. THE CONTACT MENTIONED THAT THE ELECTRONIC THROTTLE BODY SENSOR WAS REPLACED TWICE. THE VEHICLE RECENTLY WENT INTO "LIMP MODE" AGAIN. THE DEALER PERFORMED A DIAGNOSTIC TEST, BUT A FAILURE CODE COULD NOT BE FOUND. THE VEHICLE WAS ALSO TEST DRIVEN, BUT THE FAILURE WAS NOT DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000.
Feb 01, 2017
UNKNOWN OR OTHER,ENGINE
1 complaint
I AM VERY CONCERNED ABOUT MY SAFETY AND THAT OF OTHERS. MY FORD 500 , ESPECIALLY WHEN IT IS WARM AND I AM USING THE A/C, WILL WITHOUT WARNING SURGE AHEAD, AND I MUST APPLY THE BRAKES AS HARD AS I CAN . I ALMOST CRASHED WHILE ATTEMPTING TO PARK IN A HANDICAPPED SPOT IN EMERGENCY PARKING AREA AT THE HOSPITAL, WHERE I WAS TAKING MY CRITICALLY ILL HUSBAND 2 WEEKS AGO. I WAS BRAKING, BUT THE CAR WAS SURGING AHEAD. THE SAME HAPPENED WHEN I WAS LEAVING. VERY FRIGHTENING!! CAN THIS BE FIXED WITHOUT CHARGE AT MY LOCAL FORD DEALER? (GALPIN)
Sep 29, 2015
ENGINE AND ENGINE COOLING,VEHICLE SPEED CONTROL,FUEL/PROPULSION SYSTEM
1 complaint
VEHICLE WAS STALLING OUT FINALLY QUIT, HAD IT TOWED TO A FORD DEALER, WAS ADVISE THAT THE THROTTLEBODY HAD SHORTED OUT. THEY SAY IT IS NOT COVERED UNDER THE WARRANTY. THE ENGINE WAS REPLACE BY THE FORD DEALERSHIP DUE TO A MANUFACTURE DEFECT 6 YEARS AGO. THE VEHICLE HAS LESS THAT 50,000 MILES ON. WHAT ESTIMATE COST OF REPAIRING IS $970.00. WE HAVE AN EXTENDED WARRANTY COVERAGE. BUT I THINK FOR SHOULD FIX IT WITHOUT CHARGE. *TR
May 21, 2014
SUSPENSION,POWER TRAIN,ELECTRICAL SYSTEM
1 complaint
WHEN I AM IN PARK OR NEUTRAL MY MOTOR MAKES A TICKING NOISE. WHEN IN DRIVE IT HOES AWAY. WEIRD. *TR
Feb 27, 2014
ELECTRICAL SYSTEM,ENGINE
1 complaint
DURING NORMAL DRIVING VEHICLE DASH LIGHTS WENT COMPLETELY OUT AND THEN BEGAN TO FLICKER WHILE BOTH GAUGES SPEEDO AND TACH WENT LEFT TO RIGHT ON AND OFF REPEATEDLY CAUSING A LOSS OF POWER ON VEHICLE RENDERING VEHICLE UNSAFE TO DRIVE AND ALMOST CAUSING COLLISION.. BROUGHT TO FORD DEALER REPLACED ALTERNATOR AND PROBLEM STILL EXISTS AFTER 500 DOLLAR EXPENSE. *TR
Dec 06, 2013
POWER TRAIN,EXTERIOR LIGHTING,ENGINE
1 complaint
AT TIMES WHEN PLACING CAR INTO REVERSE OR DRIVE IT WILL LURCH FORWARD. WHEN GOING UP ANY HILL AND THE 6 SPEED TRANSMISSION NEEDS TO DOWN SHIFT, IT SEEMS THAT IT POPS INTO NEUTRAL AND THEN POPS INTO LOWER GEAR CAUSING THE CAR TO JERK VERY HARD.. THE JERKING CAN BE SO HARD THAT I AM SCARED THAT ITS GOING TO BREAK THE MOTOR MOUNTS OR THE DRIVE AXLES. THIS HAPPENS EVERY TIME I AM GOING UP A HILL OR TRYING TO PASS SOMEONE ON THE INTERSTATE ON FLAT LAND. HAD TO REPLACE THE LOW BEAM HEADLIGHT SOCKETS DUE TO THEM OVERHEATING AND MELTING THE SOCKET AND CAUSING THE BULBS TO STOP WORKING. THE DRIVER SIDE WINDOW, WHEN TRYING TO BRING IT UP IT WILL STOP AND GO BACK DOWN. SOMETIMES IT WILL DO IT A COUPLE TIMES BEFORE I CAN GET THE WINDOW ALL THE WAY UP. THIS IS MY FIRST FORD I HAVE EVER OWNED AND I AM LOVE WITH THE CAR BUT NOT WITH THE PROBLEMS I AM HAVING WITH THE CAR. ALSO, WHEN THE CAR HIT 100,000 MILES IT STARTED TO BURN 1 QUART OF OIL BETWEEN OIL CHANGES. I CANNOT FIND ANY LEAKS. I HAVE SEE A LOT OF PEOPLE HAVING THE SAME ISSUES I AM HAVING WITH THE LURCHING AND JERKING OF THE TRANSMISSION. WISH FORD WOULD DO A REAL CALL FOR THESE PROBLEMS BECAUSE I JUST LOVE THIS CAR! *JB
Sep 05, 2013
STRUCTURE,VEHICLE SPEED CONTROL,ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES
1 complaint
UNINTENDED ACCELERATION FROM STOP WHEN BRAKE RELEASED. FROM SEPT 2006 UNTIL PRESENT. APPROX $3000 EACH TIME. HIT GARAGE WALL. (APPROX 5 COLLISIONS WITH WALL) STILL DOES IT. FINALLY FOUND OUT WHEN & WHY. *TR
Aug 08, 2013
FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL
1 complaint
TWO PROBLEMS: 1. CAR SURGES SPORADICALLY (I.E. WHEN PULLING INTO PARKING SPACE WITH FOOT ON BRAKE, CAR SURGES AS IF PRESSING THE ACCELERATOR). 2. WHILE DRIVING ALL LIGHTS ON DASH GO OUT, SPEEDOMETER AND TACHOMETER GO TO ZERO. I HAD THE THROTTLE BODY REPLACED ONCE (SEVERAL MONTHS LATER, FORD REIMBURSED ME FOR THE COST UNDER CUSTOMER SATISFACTION PROGRAM 12N03. THIS SOLVED THE PROBLEM FOR SEVERAL MONTHS. THE PROBLEM IS NOW RE-OCCURRING. FORD HAS INDICATED THAT THEY WILL NOT REPAIR THE CAR AGAIN. THIS SEEMS TO BE A SAFETY ISSUE. *TR
Jul 28, 2013
POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM
1 complaint
VEHICLE SURGES FOR NO PARTICULAR REASON AND SHOWS. A CHECK ENGINE LIGHT ON (WRENCH). CONTROL OF ACCELERATION IS MIXED AND VEHICLE EITHER LURCHES OR FEELS AS THOUGH TRANSMISSION IS IN NEUTRAL AND RPM'S INCREASE WITHOUT ACCELERATION BY DRIVER. HAVE A SCHEDULED SERVICE CALL WITH FORD AND HAVE BEEN ISSUED A NOTICE FROM FORD THAT THIS ISSUE WILL BE COVERED. *TR
Feb 02, 2013
POWER TRAIN,ELECTRICAL SYSTEM
1 complaint
WHEN DRIVING THE CAR AND SLOWING DOWN THE CVT TRANSMISSION SURGES AHEAD AND THE CAR GOES INTO SAFE MODE ONLY ALLOWING IT TO GO 20 MPH WHEN DRIVING IN TRAFFIC. MANY NEAR MISSES ON ACCIDENTS. HAVE HAD CAR INTO DEALER 3 TIMES AND STILL UNABLE TO DIAGNOSE PROBLEM. MAINTENANCE SERVICE WAS COMPLETED ON TRANSMISSION AT 60,000 MILES PER RECOMMENDATIONS. FORD MOTOR COMPANY STATED IN A PHONE CONVERSATION THERE ARE KNOWN TRANSMISSION PROBLEMS WITH THIS CAR. DEALER STATES IT IS THE COMPUTER CAUSING THIS UNSURE WHO IS RIGHT. A TRANSMISSION SENSOR IS BEING REPLACED TO THE TUNE OF $2000. PLEASE HELP IF THIS IS A KNOWN PROBLEM. JUST HAD A PART IN THE TRANSMISSION REPLACED BECAUSE THERE WAS A RECALL ON IT. *TR
Jan 02, 2013
EXTERIOR LIGHTING,SERVICE BRAKES
1 complaint
TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH AND HAVING TO BRAKE ABRUPTLY, THERE WAS A HESITATION IN BRAKING RESPONSE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE THEY ADVISED HIM THAT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS REPAIRED AND THREE SETS OF REAR BRAKE PADS WERE INSTALLED ON THE VEHICLE. IN ADDITION, THE LOW BEAM HEADLIGHTS STARTED TO DIM. THE CONTACT INSPECTED THE VEHICLE HIMSELF AND NOTICED THAT THE PIG TAIL SOCKET HAD SHORTENED. THE PIG TAIL SOCKET WAS REPLACED. THE FAILURE MILEAGE WAS UNKNOWN. THE CURRENT MILEAGE WAS APPROXIMATELY 125,000. THE VIN WAS UNAVAILABLE.
Dec 06, 2012
STRUCTURE,LATCHES/LOCKS/LINKAGES
1 complaint
UPON STARTING THE VEHICLE THIS MORNING (FIRST SUB-FREEZING DAY HERE AND FIRST TIME THE CAR HAD NOT BEEN GARAGED), THE DRIVER DOOR DID NOT LATCH. REPEATED ATTEMPTS TO SECURE THE DOOR BOTH FROM INSIDE AND OUTSIDE THE VEHICLE FAILED. I HELD THE DOOR CLOSED FOR A 10-MINUTE DRIVE AND PARTIALLY THROUGH THE TRIP IT PARTIALLY LATCHED AND BY THE TIME I ARRIVED AT MY DESTINATION THE DOOR LATCHED AND LOCKED. THIS IS SIMILAR TO AN EXISTING RECALL FOR 2005 FORD FIVE HUNDREDS (ID #06V383000) BUT IN SPEAKING WITH FORD OWNER SERVICES I AM TOLD THE RECALL HAS NOT EXTENDED TO 2006 MODEL YEAR FIVE HUNDREDS. I BELIEVE IT IS A SITUATION TO BE INVESTIGATED AS A SAFETY HAZARD. *TR
Nov 29, 2012
ELECTRICAL SYSTEM,AIR BAGS
1 complaint
THE AIRBAG WARNING LIGHT COMES ON AND THEN THE ENTIRE GAUGE CLUSTER (I AM TALKING ABOUT THE SPEEDOMETER, THE TEMPERATURE GAUGE, THE GAS GAUGE, AND THE TACHOMETER) SHUTS OFF COMPLETELY AND COMES BACK ON RANDOMLY. TEN DAYS AFTER INITIAL INCIDENT THE AIRBAG WARNING LIGHT CAME ON AND THEN THE GAUGE CLUSTER SHUT OFF COMPLETELY AND STAYED OFF. THE SPEEDOMETER IS THE MOST IMPORTANT PART. I HAVE SEEN SEVERAL ARTICLES ONLINE ABOUT THE SAME TOPIC, AND THE BELIEF IS THAT IT IS DUE TO FAULTY SOLDERING ON THE BACK OF THE UNIT. *TR
Oct 30, 2012
POWER TRAIN,ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM
1 complaint
CAR SURGES ON ITS OWN, AFTER PUTTING IT INTO GEAR. *TR
Jul 05, 2012
VEHICLE SPEED CONTROL,SERVICE BRAKES
1 complaint
1ST ISSUE: WHEN THE VEHICLE IS AT A STOP LIGHT, THE CAR FEELS LIKE IT'S GOING TO JUMP FORWARD EVEN WHILE THE BRAKE IS DEPRESSED. I WORRY ABOUT REAR-ENDING THE CAR IN FRONT OF ME. THEN WHEN THE CAR IS IN PARK, THE CAR BEGINS TO REV OR IDLE HIGH AS IF THE ACCELERATOR HAS BEEN PRESSED. 2ND ISSUE: WHILE IN PARK OR DRIVING AT LOW SPEEDS OF 30-35MPH, THE INSTRUMENT PANEL QUITS WORKING AND THE A/C STOPS AS IF THE CAR WAS TURNED OFF. IT'LL THEN COME BACK ON AND WILL CONTINUE TO COME ON AND OFF. THE BAD THING IS THAT THE HAZARD LIGHTS WON'T EVEN WORK. THERE'S NO WARNING. WE HAVE ALREADY HAD THE THROTTLE BODY REPAIRED LAST YEAR IN 2011 WHEN WE FOUND OUT IT'S A COMMON PROBLEM BUT NOT COVERED UNDER WARRANTY NOR A RECALL ISSUED. *TR
Jul 05, 2012
POWER TRAIN,VEHICLE SPEED CONTROL,FUEL/PROPULSION SYSTEM
1 complaint
2006 FORD 500. THE CAR WILL SUDDENLY SURGE AT IDLE...IT ALSO SURGES DURING GEAR SHIFTS FROM PARK TO DRIVE AND PARK TO REVERSE. IF YOU DO NOT HAVE YOUR FOOT FIRMLY ON THE BRAKE PEDAL THE CAR WILL SUDDENLY SURGE FORWARD. THIS CAN LEAD TO DAMAGE OF THE VEHICLE OR INJURY TO A PEDESTRIAN. ARFC WEBSITE HAS 125 REPORTS OF THIS PROBLEM. SEEMS TO GET WORSE AROUND THE 60-65,000 MILE RANGE....CONVENIENTLY OUT OF WARRANTY. TAKING CAR TO DEALER TODAY FOR EVALUATION AND REPAIR. *TR
Jun 25, 2012
SEAT BELTS
1 complaint
THE DRIVERS SIDE SEAT BELT WOULD NOT RELEASE COMPLETELY WHEN PUSHING THE RELEASE BUTTON. ATTEMPTED TO PUSH THE SEAT BELT BACK INTO THE BUCKLE TO SEE IF THE RELEASE BUTTON WOULD WORK TO RELEASE THE BUCKLE. THE RELEASE BUTTON WAS STUCK DOWN IN THE BUCKLE AND I WAS UNABLE TO GET THE BELT OUT. I HAD TO CLIMB OUT OF THE SEAT BELT AND NOW I AM UNABLE TO USE THE SEAT BELT. THE FIRST THING THAT RAN THROUGH MY MIND WAS THIS SHOULDN'T HAPPEN ON A 6 YEAR OLD VEHICLE THAT HAS NEVER BEEN IN AN ACCIDENT TO MY KNOWLEDGE. (I BOUGHT THIS NEW) THEN OF COURSE MY MIND STARTS WORRYING ABOUT WHETHER THIS WILL HAPPEN TO THE OTHER SEAT BELTS AND WHETHER I WILL BE ABLE TO GET MY SON OUT IN AN EMERGENCY. I CURRENTLY NOT ABLE TO USE THE BELT AND FEEL VERY UNSAFE. OF COURSE FORD OFFERS NO HELP. I HAVE BEEN UNABLE TO MAKE AN APPOINTMENT WITH A DEALER ABOUT THE REPAIR DUE TO FAMILY DEMANDS, I AM A SINGLE PARENT WORKING FULL TIME AND MY MOTHER HAD OPEN HEART SURGERY AND NEEDS CARE AT HOME FOR AN INFECTION. I BARELY GET 5 HOURS OF SLEEP A NIGHT. I WILL BE CALLING A DEALER THIS WEEK HOWEVER, I THINK THIS IS A BIG SAFETY ISSUE FOR A 6 YEAR OLD CAR. THERE ARE CARS 20-30 YEARS OLD THAT STILL HAVE THEIR ORIGINAL SEATBELTS THAT FUNCTION. THIS PROBLEM IN MY OPINION IS BECAUSE CAR MAKERS ARE TRYING TO PUT AN EXTRA DOLLAR IN THEIR POCKET BY BUYING CHEAPER, LOWER QUALITY PARTS. *TR
Jun 18, 2012
POWER TRAIN,ELECTRICAL SYSTEM,ENGINE
1 complaint
THIS FORD FIVE HUNDRED SURGES OR REVS UP THE ENGINE, IN FORWARD OR REVERSE, WHEN DRIVING AT SLOW SPEEDS, USUALLY INTO PARKING SPACES OR AT RED LIGHTS. THIS IS A DANGEROUS SITUATION BECAUSE WE HAVE NO WARNING THAT IT IS ABOUT TO HAPPEN. I HAVE NOTICED IT IS WORSE IF THE A/C IS ON. WE HAVE AVOIDED SEVERAL ACCIDENTS BY SLAMMING ON THE BRAKE, IT WILL EVEN CONTINUE TO SURGE IF THE BRAKE PEDAL IS HELD HARD TO THE FLOOR. THE VEHICLE STARTED DOING THIS WITHIN THE FIRST 150 MILES THAT WE OWNED IT. THE INCIDENTS ARE UNPREDICTABLE AND DANGEROUS. *TR
Jun 17, 2012
EXTERIOR LIGHTING,ELECTRICAL SYSTEM
1 complaint
DASH CLUSTER MALFUNCTION FOR ALL GAUGES. AT THE TIME OF MALFUNCTION, REVERSE LAMPS TURN ON. IF MALFUNCTION OCCURS AT NIGHT, DASH ILLUMINATION ALSO SHUTS DOWN. GAUGES ZERO OUT, TOP OUT THEN FLUTTER AT ZERO. *JS HAVE NOTICED AIRBAG LAMP ON OCCASIONALLY. *JS
May 15, 2012
ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE
1 complaint
CRUISING APPROX 65 MPH. I HEARD A THUD (LIKE RUNNING OVER A POT HOLE). THE CAR LURCHED FWD THEN SEEMED TO SHUT OFF, HOWEVER IT WAS STILL RUNNING. THE RPM DROPPED BELOW 1000 AND THE THROTTLE WOULD NOT WORK. PLACED CAR IN NEUTRAL AND MOVED TO THE SIDE OF THE ROAD. NOTICED THE WRENCH LITE WAS ILLUMINATED. TURNED THE CAR OFF AND RESTARTED. THE CAR SEEMED TO DRIVE FINE AFTER THAT WITH NO LITE. TOOK THE CAR TO HAVE THE CODES CHECKED. TWO CODES SHOWED: THROTTLE STUCK CLOSED AND THE THROTTLE FORCED TO IDLE (APPARENTLY A SAFETY FEATURE). TWO DAYS AGO HAD TO HAVE THE PCM AND TCM UPDATED AND REPLACED THE UPPER MOTOR MOUNT. FROM PREVIOUS COMPLAINTS THERE ARE SEVERAL WITH THE CAR TAKING OFF AND A FEW OF WITH MY ISSUE. ALL SEEMED TO BE ATTRIBUTED TO THE THROTTLE BODY MALFUNCTIONING WHICH IS APPARENTLY THE CASE HERE. GIVEN THE AMOUNT OF COMPLAINTS AND ISSUES CONCERNING THIS ITEM, SURELY THERE IS A RECALL REQUIRED. AT THE VERY LEAST THE MANUFACTURE SHOULD GIVE US WHAT WE PAID FOR THE VEHICLE AS CREDIT TOWARD ANOTHER CAR (ANY MAKE AND MODEL) IF THEY ARE NO GOING TO FIX THE PROBLEM. *TR
Nov 07, 2011
SERVICE BRAKES, HYDRAULIC,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL
1 complaint
THE INSTRUMENT CLUSTER CHECKS NORMAL ON MOST START-UPS, BUT UNPREDICTABLY ALL SYSTEMS LIGHT UP SHOWING FAILURE OF ABS, AIR BAGS, TRACTION CONTROL, ELECTRICAL SYSTEMS, SEE A MECHANIC, CRUISE CONTROL AND SPEEDOMETER QUITS WORKING. THE WARNING LIGHTS MAY STAY LIT FOR 2 TO 200 MILES. AND NO SPEEDOMETER. AUTO ZONE AND MY MECHANIC ARE BAFFLED AND FRUSTRATED AFTER CHECKING BATTERY CHARGING CIRCUIT CONNECTIONS AND GROUNDS. ITS OBVIOUSLY NOT SAFE DRIVING WITHOUT KNOWING YOUR SPEED OR IF THERE IS A MAJOR HAZARD LOOMING-----LIKE FIRE. *TR
Oct 16, 2011
FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM,ELECTRONIC STABILITY CONTROL (ESC)
1 complaint
MY FORD FIVE HUNDRED THROTTLE JUST SHUTS DOWN,WITH NO WARNING AT ALL. I AM AFRAID TO DRIVE IT BECAUSE IT MAY SHUT DOWN IN TRAFFIC AND SOME GET SERIOUSLY HURT. I HAVE SEARCHED THE INTERNET AND FOUND MORE COMPLAINTS SAME AS MINE. THE PROBLEM IS WITH A THROTTLE BODY MALFUNCTION. SOME THING SHOULD DONE BEFORE SOMEONE IS KILLED! *TR
Sep 05, 2011
ENGINE AND ENGINE COOLING,EQUIPMENT
1 complaint
A/C COMPRESSOR FAILED , ONLY WORKED WHEN AT HIGHWAY SPEED. PER REPUTABLE A/C MECHANIC THIS IS A PROBLEM WITH FORD 500'S.CALLED FORD MOTOR COMPANY IN DETROIT 7/13/11, FORD WILL NOT COVER REPAIR, BUT I WAS TOLD THERE HAVE BEEN SEVERAL INCIDENTS FOR A/C FAILURE. FORD TOLD ME TO KEEP MY RECEIPT IN CASE FORD SOME DAY DECIDES TO COVER IT. FORD KNOWS IT HAS A PROBLEM, BUT NOT WILLING TO COVER IT , UNTIL THEY ARE FORCED TO COVER IT BY NHTSA MAYBE? *TR
Jul 27, 2011
VEHICLE SPEED CONTROL,UNKNOWN OR OTHER
1 complaint
WHILE PUTTING THE FORD FIVE HUNDRED IN REVERSE THE CAR BRIEFLY ACCELERATED AND LUNGED BACKWARDS BARLEY MISSING ANOTHER CAR. THINKING I MIGHT HAD HIT THE ACCELERATOR I WENT ON TO WHERE I WAS HEADED. AS I WAS LEAVING MY DESTINATION ONCE AGAIN THE CAR JUST TOOK OFF WHILE IN REVERSE. THE CAR THEN GAVE A WRENCH FAULT ON THE CONSOLE. I LOOKED UP THE ISSUE IN THE MANUAL AND IT SAID IT WAS A THROTTLE CONTROL ISSUE. I SPOKE WITH THE DEALER TODAY AND THEY SAID IT WAS A THROTTLE BODY PROBLEM. UPON INVESTIGATION I FIND THAT THIS IS A RECURRING ISSUE. IF SOMEONE HAD BEEN WITHIN 3 TO 5 FEET OF MY AUTO I WOULD HAVE HIT THEM.
Jul 19, 2011
POWER TRAIN,CHILD SEAT
1 complaint
2006 FORD FIVE HUNDRED, LUNGES FORWARD UNEXPECTEDLY, AIR CONDITIONER DOES NOT WORK PROPERLY, DOES NOT ACCELERATE TO FULL POTENTIAL, WRENCH LIGHT CAME OUT AFTER WEEKS OF THIS PROBLEM HAPPENING. POWER TRAIN AND TRANSMISSION PROBLEM. WHEN PUT IN REVERSE IT ACCELERATES WITH FOOT STILL ON BRAKE, COULD CAUSE AN ACCIDENT. NEED TO BE RECALLED VARIOUS COMPLAINTS SEEN ON-LINE!! WRENCH LIGHTS COMES ON AND OFF. (RELATED VEHICLE INFORMATION: MODEL YEAR=2006, MAKE=FIVE HUNDRED, MODEL=FORD). *TR
Jul 09, 2011
ELECTRICAL SYSTEM,ELECTRONIC STABILITY CONTROL (ESC)
1 complaint
I HAD A 2006 FORD FIVE HUNDRED AT FIRST I LOVED THAT CAR THEN THE BATTERY STARED GOING DEAD SO I REPLACED THE BATTERY BUT IT STILL DID IT SO I HAD IT LOOKED AT AND THEY TOLD ME THAT IT WAS THE ALTERNATOR GOING OUT SO I REPLACED THAT BUT COME TO FIND OUT AFTER 2 BATTERIES AND 3 ALTERNATORS IT WAS A WIRING PROBLEM AND FINALLY THE WIRING PROBLEM ENDED UP FRYING THE COM[UTER IN MY CAR AND IT WAS GOING TO COST ME A WHOLE LOT OF MONEY TO FIX IT AND I DIDN'T HAVE THAT TYPE OF MONEY IT WAS MORE MONEY THEN THE CAR WAS WORTH I HAVE TALKED TO SEVERAL PEOPLE WHO SAY THAT THEY HAVE HAD THE SAME PROBLEM SO A WORD TO THE WISE DO NOT BUY A FORD FIVE HUNDRED !!! *TR
Jan 11, 2011
POWER TRAIN,VEHICLE SPEED CONTROL,EQUIPMENT
1 complaint
STARTING SINCE FEBRUARY 2010. MY CAR LUNGES FORWARD WHENEVER AT A DEAD STOP. WHEN SHIFTING TO DRIVE AND REVERSE. I HAVE HAD TO HAVE MY FOOT ON BRAKE AND EVEN ALMOST HAD AN ACCIDENT WHILE PARKING AND HIT THE WALL. WENT TO DEALERSHIP AND FIRST THEY SAID IT WAS MY ENGINE MOUNT THAT WAS CAUSING IT. THEN WENT AGAIN BECAUSE THE PROBLEM STILL OCCURRED AND THEY SAID I NEEDED A NEW BATTERY. THEN THEY CLAIMED IT WAS MY AIR FILTER WHICH IS A LIE. I CALLED THE FORD HEADQUARTERS AND ALL THEY CAN DO IS TAKE DOWN WHEN I CALLED AND WHAT IT WAS ABOUT. THEY ARE NO HELP WHAT SO EVER SO WHAT IS THE POINT OF THEM EVEN EXISTING IF THEY CANT HELP SOLVE THE PROBLEM. THEY CLAIM EACH DEALER IS INDEPENDENT AND THAT THEY CAN ADVISE THAT I GO TO A DIFFERENT DEALERSHIP. I HAVE WASTED A GOOD DEAL OF TIME AND MONEY. LUCKILY I WAS SMART AND BOUGHT THAT PREMIUM EXTENDED WARRANTY. I STILL HAVE SPENT CLOSE TO OVER $400 ON REPAIRS. EACH TIME I WENT I HAD TO PAY A DEDUCTIBLE OF $100.00. THE BATTERY I WENT TO SAMS CLUB TO GET BECAUSE THE DEALER WANTED $140 BUT I GOT MINE FOR $75. THEY ADVISED TO GET MY THROTTLE BODY CLEAN AND THAT WAS $95. THEY SAID I NEED TO HAVE MY TRANSMISSION FLUSHED WHICH IS ANOTHER LIE. I DIDN'T GET THAT DONE BECAUSE I ONLY HAVE 60,000 MILES ON THE VEHICLE. THE TRANSMISSION FLUID WAS AS RED AS CAN BE AND IS STILL GOOD FOR PROBABLY ANOTHER 40,000 MILES. THE POINT IS FORD KNOWS ABOUT THE PROBLEM AND THEY DO NOT WANT TO FIX THE PROBLEM IT APPARENTLY IS HAPPENING TO TONS OF FOLKS OUT THERE. THEY NEED TO JUST FIX IT BECAUSE EVEN THOUGH I HAD MY THROTTLE BODY CLEANED THE PROBLEM STILL COMES BACK HERE AND THERE. I JUST HOPE THAT NO ONE GETS KILLED AND THEN FORD WILL FINALLY GET THIS RIGHT. I PLAN ON SEEING IF I CAN GET SOME LEGAL HELP AND WILL EXPLORE THAT AVENUE BECAUSE I GET MY OIL CHANGES ALMOST EVER 3500 MILES AND I FOLLOW ALL THE MANUFACTURES SERVICE POLICIES. I DO MY PART AS A CUSTOMER AND THEY HAVEN'T DONE THERE PART AS THE COMPANY THAT MADE THE VEHICLE. *TR
Dec 29, 2010
SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM,VISIBILITY
1 complaint
2006 FORD FIVE HUNDRED. CONSUMER WRITES REGARDING PREMATURE PAD AND ROTOR WEAR *TGW THE CONSUMER STATED SHE HEARD A GRINDING NOISE AND/OR DRAGGING NOISE COMING FROM THE REAR WHEELS. THE LEFT AND RIGHT WHEELS NEEDED NEW BRAKES AND ROTORS. THE CONSUMER STATED AN EXTENDED WARRANTY HAD BEEN ISSUED FOR THE BRAKES IN 2007, BECAUSE FORD KNEW THERE WAS A PROBLEM. ALSO, THE BLOWER MOTOR BEHIND THE GLOVE BOX HAD TO BE REPLACED AND THE REAR WINDOW DEFROSTER WAS DEFECTIVE AND HAD TO BE REPLACED AS WELL. THE GASKET BETWEEN THE CRANK SHAFT SUPPORT HOUSING WAS REPLACED. *JB
Oct 01, 2010
ELECTRONIC STABILITY CONTROL (ESC)
1 complaint
MY CAR STARTED LUNGING FORWARD AND DYING WHEN I WAS EITHER IDLE OR WHEN I STOPPED AND STARTED UP AGAIN. THE THROTTLE LIGHT AND ENGINE LIGHT CAME ON. SOMETIMES WHEN YOU WOULD TURN THE IGNITION OFF AND THEN RESTART THE THROTTLE LIGHT WOULD GO OFF. I HAVE NOTICED SOME DIFFERENCE IN FUEL MILEAGE. IF I DON'T HAVE MY FOOT ON THE BRAKE AND IT STARTS FORWARD SOMETIMES IT WOULD LUNGE, BUT NOT ALL THE TIME. I HAVE TAKEN IT TO GET THE COMPUTER FLASHED BY A GOODYEAR PLACE IN NORTH LITTLE ROCK, AR. IT HAS OCCURRED SEVERAL TIMES MORE SINCE THEY FLASHED IT. THAT WAS ABOUT THREE WEEKS AGO. THE DATE NOW IS SEPT. 20. I WANTED TO REPORT IT, BECAUSE WITH THE LUNGING IN HEAVY TRAFFIC, I AM AFRAID THAT I WILL REAR END SOMEONE ALL BECAUSE OF THE LUNGING, WHICH IS UNEXPECTED. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*TR
Sep 20, 2010
VEHICLE SPEED CONTROL,EQUIPMENT
1 complaint
AFTER HAVING BEEN DRIVEN FOR 30-45 MIN, THE CAR WAS PARKED WITH MOTOR RUNNING FOR 5-10 MIN. GOT BACK IN CAR, PUT FOOT ON BREAK PEDAL, SHIFTED CAR INTO REVERSE, LIFTED FOOT OFF BREAK PEDAL AND CAR SUDDENLY LURCHED BACKWARDS. SLAMMED BREAKS ON AND CAR SHUT OFF. CAR HAD NO PROBLEM CRANKING RIGHT UP. DID THE SAME THING AGAIN, ONLY THIS TIME I HAD IT IN DRIVE. HIT THE BREAKS, CAR DIES AGAIN. THIS HAS HAPPENED A FEW TIMES WHILE SITTING IN LINE AT A FAST FOOD DRIVE-THRU AND HAVE ALMOST HIT CARS INFRONT OF ME WHEN I GO TO MOVE UP IN THE LINE. IF YOU TURN THE CAR ALL THE WAY OFF, IT WILL RESET AND NOT HAVE ANY PROBLEMS UNTIL THE NEXT TIME IT DECIDES TO DO IT AGAIN. I SEEM TO BE ABLE TO ELICIT THE PROBLEM BY DRIVING THE CAR FOR 30 OR SO MINUTES, STOPPING AND LETTING THE CAR SIT AND IDLE FOR 5-10 MINUTES. BINGO- IT HAPPENS. FORD DEALERSHIP SAYS IT IS THE THROTTLE BODY ON MY 2006 FORD FIVE HUNDRED AND I ACTUALLY HAD IT REPLACED IN 2007 AT APPROX 23,000 MILES (I NOW HAVE 69,500 MILES). CAR IS AWD. THANK GOD I HAVE AN EXTENDED WARRANTY UNTIL 75,000 MILES THAT WILL COVER THIS BUT IT SEEMS THE PART TO FIX IT IS ON BACKORDER AND THEY ARE NOT SURE WHEN IT WILL BE AVAILABLE (THAT IS RIDICULOUS CONSIDERING HOW MUCH I HAVE READ ABOUT "THROTTLE BODY ISSUES" WITH THIS CAR.) I THINK IT SHOULD BE A RECALL ISSUE SINCE YOU COULD EASILY HIT SOMETHING INFRONT OR BEHIND YOU. THANKS FOR LETTING ME INFORM YOU OF THIS PROBLEM. *TR
Aug 07, 2010
SERVICE BRAKES, HYDRAULIC,PARKING BRAKE
1 complaint
REAR BRAKES PREMATURELY WEAR DOWN TO LESS THAN 2MM OF PAD REMAINING AFTER 11K MILES. *TR
Apr 08, 2010
SERVICE BRAKES, HYDRAULIC,AIR BAGS
1 complaint
TRAVELING SOUTH ON I-26 ACROSS THE TN/NC BORDER THROUGH SAM'S GAP ON A SNOWY DAY LED ME TO DRIVE VERY SLOW AND COME TO A STOP AT THE TRUCK INFORMATION AREA AT THE TOP OF THE HILL. WHEN I SAW A LARGE TRANSFER TRUCK PULL OUT ONTO THE ROAD AND PROCEED DOWN THE HILL I FELT IT WAS SAFE TO FOLLOW. THIS TRUCK WAS MOVING A LOT FASTER THAN I WAS AND I WAS "COVERING THE BRAKE" AND TAPPING IT OCCASIONALLY DOWN THE STEEP INCLINE, BUT THERE WAS ICE ON THE ROAD AND WHEN I TAPPED THE BRAKES THE CAR BEGAN TO SPIN AND HIT THE CONCRETE MEDIAN ON ALL 4 CORNERS OF THE VEHICLE WITH PRETTY STRONG FORCE. THE SEAT BELT CORRECTLY LOCKED DOWN ON THE DRIVER SIDE, BUT THE AIR BAG DID NOT DEPLOY PROPERLY. THE AIR BAG LIGHT WAS ILLUMINATED AND I COULD SMELL LIKE SOMETHING WAS BURNING. I ASSUMED THIS WAS THE COMPOUND USED IN THE AIR BAG. WHEN THE POLICE ARRIVED, I WAS GIVEN A CITATION FOR DRIVING TOO FAST FOR THE CONDITIONS AND ANOTHER BECAUSE THE INSURANCE RECENTLY LAPSED. THE TOW TRUCK DRIVER TOOK THE CAR TO THE BOTTOM OF THE HILL (DRIVING TOO FAST FOR THE CONDITIONS BY THE WAY) AND DECLARED THE CAR DRIVABLE SINCE THERE WERE NO FLUIDS LEAKING AND THE CAR WOULD STILL CRANK. THE FUEL SYSTEM HAD TO BE RESET, BECAUSE IT CORRECTLY SHUT OFF DUE TO THE IMPACT. THE SEATBELT WAS LOCKED DOWN COMPLETELY AND WOULD NOT RELEASE. SINCE THERE WAS NO SNOW BEYOND THE SAM'S GAP AREA, I DECIDED TO DRIVE HOME AND PARK THE CAR BECAUSE I DID NOT HAVE MONEY FOR A HOTEL OR FOR ADDITIONAL TOWING AND THE PERSON AT THE NC WELCOME CENTER SAID WE WERE EXPERIENCING BLIZZARD CONDITIONS. SO RATHER THAN FREEZE TO DEATH OR ASK SOMEONE ELSE TO PUT THEMSELVES IN DANGER TO COME GET ME I DROVE HIM WITH THE AIRBAG / SEATBELT LIGHTS ALARMING. THE BODY SHOP PERSON I SPOKE WITH SAID THAT I NEEDED TO DETERMINE WHAT IS WRONG WITH THE RESTRAINT/AIRBAG SYSTEM BEFORE THEY CAN WORK ON IT BECAUSE OF THE RISK OF THE SYSTEM DEPLOYING WITHOUT WARNING. *TR
Feb 17, 2010
STEERING,SERVICE BRAKES, HYDRAULIC
1 complaint
IN JUNE 2007, MY WIFE TOOK OUR 2006 FORD FIVE HUNDRED (SEL) TO THE LOCAL DEALER FOR AN OIL CHANGE. SHE WAS INFORMED AT THE TIME THAT SHE NEEDED TO HAVE THE REAR BRAKE PADS REPLACED. THE CAR HAD ONLY 26,800 MILES ON IT. I WAS IN DISBELIEF AND TOLD HER NOT TO ALLOW THE WORK. I TOOK THE CAR TO AN AUTO SERVICE CENTER THAT I TRUSTED THE NEXT DAY. SURE ENOUGH, THE PADS NEEDED TO BE REPLACED. I HAD THEM DO THE WORK. I THEN COMPLAINED TO THE LOCAL DEALER THAT THIS WEAR RATE WAS UNACCEPTABLE AND CARS NORMALLY GO SIGNIFICANTLY LONGER BEFORE NEEDING REAR PAD REPLACEMENT. I RECEIVED A LETTER FROM THEM STATING THAT THE "BRAKE WEAR ON YOUR VEHICLE IS CONSIDERED TO BE WITHIN NORMAL PARAMETERS" . I KNEW THIS WAS NOT TRUE. IN JULY, I RECEIVED A LETTER FROM FORD MOTOR CO. STATING THAT THEY WERE EXTENDING THE WARRANTY ON THE REAR PADS TO 36,000. I RECEIVED A REFUND FROM THE DEALER. JUST RECENTLY AT 68,584 MILES, WE HAD TO HAVE THE PADS REPLACED ONCE AGAIN. I DON'T THINK THIS IS ACCEPTABLE WEAR FOR THESE PADS. IT COST US $227.01 TO HAVE THEM REPLACED. MY WIFE USES THIS CAR FOR BUSINESS, SO IT LOOKS LIKE WE'LL NEED TO PLAN ON REPLACING THESE PADS EVERY YEAR. INTERESTINGLY, THE FRONT PADS HAVE NOT WORN OUT YET. THE SECOND PROBLEM WE HAVE HAD IS WITH THE TIE ROD END LINKS WHICH NEEDED TO BE REPLACED AT 53,671 MILES. I HAVE NEVER HAD TO PERFORM THIS REPLACEMENT ON ANY OTHER VEHICLE I'VE OWNED, MANY HAVE GONE WELL OVER 100,000 MILES. I BELIEVE THERE IS A DESIGN PROBLEM WITH THE CAR IN THIS RESPECT. *TR
Apr 17, 2009
SERVICE BRAKES, HYDRAULIC,TIRES,WHEELS
1 complaint
THERE WAS A RECALL ON THE BRAKES/ROTORS ON THIS VEHICLE. I HAVE HAD THEM REPLACED 2 YEARS STRAIGHT AND NOW THIS IS THE THIRD YEAR AND THE SAME PROBLEM IS DEVELOPING. THE FIRST REPLACEMENT WAS PAID FOR BY FORD. A YEAR LATER, CROWN FORD INFORMED ME THAT I WOULD HAVE TO PAY, BUT REDUCED THE COST BY ONLY CHARGING ME FOR PARTS, WHICH WAS OVER $300.00+. UPON GETTING A FRONT-END ALIGNMENT, I WAS TOLD BY FIRESTONE THAT THE REAR ROTORS WILL SOON NEED TO BE REPLACED. THERE IS A PROBLEM HERE WITH THIS CAR AND BRAKES AND I FEEL I AM BEING MISLEAD. MY FORD 2006 WAS PURCHASED IN DECEMBER 2005. *TR
Mar 18, 2009
SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING,POWER TRAIN,AIR BAGS,VEHICLE SPEED CONTROL
1 complaint
TL*THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. EVER SINCE THE VEHICLE WAS PURCHASED BRAND NEW IN 2006, THE CONTACT HAS BEEN EXPERIENCING BRAKE FAILURE. IN ADDITION, WHILE DRIVING 55 MPH, THE VEHICLE DECELERATES UNEXPECTEDLY. THE VEHICLE WAS TAKEN TO THE DEALER A TOTAL OF SIX TIMES AND THEY REPLACED THE THROTTLE AND CHANGED THE BRAKES EACH TIME. THE VEHICLE FAILED COMPLETELY AND WAS TOWED TO HER RESIDENCE. THE FAILURE MILEAGE WAS 23,000 AND CURRENT MILEAGE WAS 45,922. UPDATED 3/3/09 *CN THE AIR BAG ILLUMINATED WHEN A PASSENGER SAT IN THE SEAT. THE SHIFTER WAS HARD TO MOVE. THE FRONT MOTOR MOUNT WAS BROKEN. UPDATED 03/04/09. *JB
Jan 26, 2009
ENGINE AND ENGINE COOLING,POWER TRAIN,VEHICLE SPEED CONTROL,SERVICE BRAKES, ELECTRIC,ELECTRONIC STABILITY CONTROL (ESC)
1 complaint
ON JAN 8, 2009, I HAD TRAVELED APPROXIMATELY 1050 MILES FROM OKLAHOMA TO OHIO. WHILE IN OHIO, 6 INCHES OF SNOW HAD FALLEN, AND THE ROADS WERE SLICK WITH SNOW AND ICE. IN PREPARING FOR MY RETURN TRIP ON JAN 11, THE TRACTION CONTROL AND ABS WARNING LIGHTS CAME ON, AND THERE WAS A SIGNIFICANT CHANGE IN CONTROL AND BRAKING IN THE VEHICLE. UPON DRIVING FURTHER, THE TRANSMISSION WARNING LIGHT CAME ON, AND THE VEHICLE WENT INTO REVERSE WITH A HUGE "BANG" SOUND AND VIBRATION. THE VEHICLE'S CVT TRANSMISSION WOULD NOT CHANGE GEARS IN DRIVE WHEN THE TRANSMISSION LIGHT WAS ILLUMINATED. UPON TURNING THE VEHICLE OFF, AND BACK ON, ALL LIGHTS WOULD GO OFF, AND COME BACK ON WITHIN 5 MINUTES. AFTER THE 6TH RESTART, THE CHECK ENGINE LIGHT CAME ON AS WELL. THE TRANSMISSION LIGHT, AFTER A FEW RESTARTS, DID NOT COME BACK ON. HOWEVER, THE ABS, TRACTION CONTROL AND CHECK ENGINE LIGHTS STAYED ON FOR APPROXIMATELY 650 MILES. AFTER THAT TIME, ALL LIGHTS WENT OUT, BUT THE RPMS WENT FROM 2000 TO 3500 ON THEIR OWN WHILE THE VEHICLE WAS IN CRUISE CONTROL ON A FLAT ROAD. THAT CORRECTED ITSELF ABOUT 100 MILES LATER. UPON TAKING THE VEHICLE TO A DEALER ON MY RETURN, THEY TOLD ME THAT SINCE NO LIGHTS WERE ON, AND THE VEHICLE WAS NOW ACTING NORMALLY, THEY COULD NOT DUPLICATE THE PROBLEM. MY FACTORY WARRANTY EXPIRES IN 14 DAYS, AND I AM NOT SURE IF I'LL BE ABLE TO DUPLICATE THE PROBLEM TO THE DEALER BY THAT TIME. THE SERVICE DEPARTMENT BLAMED THE MALFUNCTION ON THE COLD WEATHER AND THE SNOW, BUT THE AWD VEHICLE WITH TRACTION CONTROL WAS, TO MY KNOWLEDGE, MANUFACTURED TO DEAL WITH SNOW AND COLD WEATHER. ONE DOES NOT NEED AWD, TRACTION CONTROL OR ABS DURING DRY, WARM DAYS. *TR
Jan 13, 2009
POWER TRAIN,VISIBILITY,STRUCTURE,ELECTRICAL SYSTEM
1 complaint
WE HAVE A 2006 FORD 500 WHICH HAD THE CVT TRANSMISSION REPLACED AFTER 4 WEEKS. THE TRANSMISSION CONTINUES TO HAVE A SIGNIFICANT DELAY IN ENGAGING IN REVERSE. MY WIFE AND DAUGHTER DID NOT WAIT UNTIL THE TRANSMISSION ENGAGED AND HAVE ON OCCASION LURCHED BACKWARDS ALMOST RUNNING OVER HER LITTLE BROTHER. WITH THE FRONT OF THE CAR ON A DECLINE THE CAR WILL ROLL FORWARD WHEN IN REVERSE UNTIL IT ENGAGES AND THE USER DEPRESSES THE THROTTLE. OLATHE FORD AND A FACTORY REP. INSPECTED THE VEHICLE AND SUPPOSEDLY THE VEHICLE IS WITHIN SPECS. I DON'T THINK SO, THE CAR ALSO WHINES WHEN TURNING CORNERS. I THINK THE CVT TRANSMISSION IS OUT OF SPECS. FORD DOESN'T USE IT ANYMORE, NOR DO I WANT TO. I HAVE HAD MANY FORDS, THIS WILL BE MY LAST IF THIS ISN'T RESOLVED TO MY SATISFACTION. THE CAR ALSO HAS THE INSTRUMENT CLUSTER WHICH INTERMITTENTLY GOES OUT, WINDSHIELD LEAKS WATER AND AIR. ANSWER SOON, I AM GOING TO BBB, NHTSA AND KANSAS CONSUMER PROTECTION. THIS CAR IS A LEMON, I WANT A WORKING ONE. *TR
Feb 18, 2008
SUSPENSION,ELECTRICAL SYSTEM,TIRES
1 complaint
TL*THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. THE CONTACT TOOK HIS VEHICLE TO THE DEALER FOR SCHEDULED MAINTENANCE AND THEY DISCOVERED THAT THE FRONT DRIVER SIDE TIRE HAD EXCESSIVE WEAR. THE CONTACT HAD THE VEHICLE ALIGNED AND THE STRUTS CHANGED AT THAT TIME. THE CURRENT MILEAGE IS 30,000 AND FAILURE MILEAGE WAS 29,000. THE CONSUMER STATED THE TIRES WERE ONLY DAMAGED ON THE LEFT SIDE, AND THEY HAD TO LOWER THE STRUTS AND ROTATE THE UPPER MOUNTS TO GET VEHICLE TO ALIGN PROPERLY. THE CONSUMER FURTHER STATED THAT THIS NO FAULT OF THE DEALER BUT THAT FORD AUTHORIZE 50% REIMBURSEMENT FOR THE TIRES AND NONE FOR THE ALIGNMENT. THE CONSUMER PROVIDED A COPY OF THE REPAIR INVOICE. THE DEALER STATED VEHICLE STARTS AND STALLS IN THE COLD WHEN USING THE REMOTE START. UPDATED 08/07/07 *TR
Jul 13, 2007
SEATS
1 complaint
DT*: THE CONTACT STATED THE VEHICLE HAS A STATIC BUILD UP AND ABOUT EIGHTY PERCENT OF THE TIME THE CONTACT EXITS THE VEHICLE THEY ARE SHOCKED. THIS ONLY OCCURS WHILE EXITING NOT ENTERING THE VEHICLE. THIS HAS HAPPENED SINCE THE VEHICLE WAS NEW AND THE DEALER DETERMINED IT IS THE CLOTH SEATS AND IS NOT FIXABLE.
Aug 21, 2006
VISIBILITY,STRUCTURE
1 complaint
I HAVE A 2006 FORD 500 THAT HAS A VERY BAD GLARE ON THE WINDSHIELD. WHEN I INQUIRES ABOUT THE PROBLEM, I WAS TOLD THERE WAS 3 SUCH COMPLAINTS MADE AT THAT SAME DEALERSHIP. I WAS ALSO TOLD THERE WAS NOTHING THAT COULD BE DONE, IT WAS CAUSED BY THE WAY THE GLASS WAS MADE. *NM
Aug 06, 2006
EQUIPMENT ADAPTIVE/MOBILITY,BACK OVER PREVENTION
1 complaint
THE REVERSE SENSING SYSTEM WORKED FLAWLESSLY FOR THE FIRST 5000 MILES. NOW IT GOES OFF EVERYTIME I PUT THE CAR IN REVERSE WHEN THERE IS NOTHING NEAR THE REAR OF THE CAR. NOW I DISREGARD THE WARNING BEEPS WHICH IS DANGEROUS. *JB
Mar 22, 2006
Frequently Asked Questions
How many problems does the 2006 FORD Five Hundred have?
The 2006 FORD Five Hundred currently has 364 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.
What are the most common problems with 2006 FORD Five Hundred?
The most common problems reported for the 2006 FORD Five Hundred are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.
Where does this 2006 FORD Five Hundred problem data come from?
All problem and complaint data for the 2006 FORD Five Hundred comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.
Other Years - FORD Five Hundred
2024 Problems
2023 Problems
2022 Problems
2021 Problems
2020 Problems
2019 Problems
2018 Problems
2017 Problems
2016 Problems
2015 Problems
2014 Problems
2013 Problems
2012 Problems
2011 Problems
2010 Problems
2009 Problems
2008 Problems
2007 Problems
2005 Problems
2004 Problems
2003 Problems
2002 Problems
2001 Problems
2000 Problems
1999 Problems
1998 Problems
1997 Problems
1996 Problems
1995 Problems
1994 Problems
1993 Problems
1992 Problems
1991 Problems
1990 Problems
Other FORD Models
'34
1500 Foldaway
A8513
A9513
A9522
Aerostar
Affordable Aluminum
Affordable Trailers
Aspire
AT8513
AT9513
AT9522
Similar Brands
ST
3,555 models
RS
3,484 models
NC
2,822 models
ND
2,385 models
Z
1,951 models
MOTO
1,583 models
NU
1,189 models
RC
1,122 models