2022 LINCOLN Aviator Problems & Complaints

Rear door trim came loose and fell off while driving. Had the service department at the local dealership look at the missing trim on the rear of the car and they noticed multiple of the plastic clips holding the trim on the rear were broken and remained in the area where the trim was attached.

The contact owns a 2022 Lincoln Aviator. The contact stated that while driving at 30 MPH, the trim pieces on the liftgate partially detached. A dealer was contacted. The vehicle was not taken to a dealer or independent mechanic to be diagnosed; however, the vehicle received an unknown recall repair and was provided an estimate for the repair. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The failure mileage was 3,333.

The contact owns a 2022 Lincoln Aviator. The contact stated that there was an unusual sound of water running from the roof of the vehicle. The contact stated that the sound was similar gushing water. The contact also stated that when the air condition was turned on, there was a moldy odor coming through the vents. The vehicle was taken to the dealer. The failure was diagnosed with an engineering error during manufacturing. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 20,000.

Vehicle had roof leak which resulted in visible water stains on roof liner, issue persists with now having rust stains on liner from the same area the roof leak was occurring.

While driving down GA 140 near Waleska, GA, I hit a bump in the highway and the hood popped open. It stopped at first catch and I was able to stop before hood came all the way up. Was able to open hood completely and relatch successfully. No further incident's but it was very stressful to get the vehicle stopped and correct the problem before the hood opened beyond the first latch and would have come up and stopped my view of the highway which had a lot of traffic. This is only incident I have had with hood popping open by itself just by hitting a bump in the road.

The contact owns a 2022 Lincoln Aviator. The contact received notification of NHTSA Campaign Number: 24V368000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and confirmed that parts were not yet available and informed the contact that the part needed to be ordered. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2022 Lincoln Aviator. The contact stated that after switching to the reverse position, the backup camera image failed to display, and while driving approximately five MPH in reverse the vehicle crashed into the front end of a second vehicle. During the crash, the occupant in the second vehicle sustained an unspecified injury that did not require immediate medical attention. No further information was available. A police report was taken at the scene and the vehicle was towed away. The cause of the failure was not determined. The manufacturer and local dealer were not notified of the failure. The contact indicated that the backup camera was previously replaced due to inoperability. The failure mileage was 28,000.

I had several instances and two minor collisions now where the back up camera glitches as well as the warning alert. I’ve come close to hitting object only to stop just in time, however in these two collisions I was I situations where I needed to maneuver faster and needed accurate guidance. I dont recall the screen ever showing up until after the collisions and the louder long warning tone went off right at or just after impact. Both times have cause damage to my car. I’ve never had issues with minor self involved car accidents. My driving record is clean. Reading about the back up camera recalls for the 20 and 21 models sound like what is happening with my car but also with the alert system. There are glitches keeping this safety feature from meeting much needed driving assurance.

The vehicle back up camera and computer screen went totally dark and would not come back on, so that when I backed out of the garage, I could not see on the rear side of the vehicle, as to any pedestrians walking across my driveway , beside nor behind my vehicle. I drove the vehicle back into the garage and ran my errand in our other car. When I came back from the errand, I tried to get the screen up again, by starting the car, and the HOME page came on the screen, and when I put the vehicle in reverse, it once again, showed the rear view of the driveway and cross way, to see that there was no pedestrian behind me; putting any neighbor child who ran across my drive while the garage walls blocked them from my view, in danger. After that one instance, it hasn't done it since. Today, while in shop for routine maintenance, I mentioned it to the Service Advisor. He said "There's a recall out on that, " I said ,"will you fix it today while I'm here?" He said , "yes'. At home, upon reviewing paperwork ,about what was done, no mention of fixing the recall, nor seeing why the camera screen went dark, was made. So, I called the Dealer and was told "There is no outstanding recall on your vehicle" They have told me I may make an appointment to leave my car at least a day for them to diagnose the problem. There was no warning , before the backup screen on my dash went totally dark. This was one time and, on May 27, 2022. Our vehicle barely has 1000 miles on it. We bought it new in January, 2022. Since the Dealership did not write down my complaint, I decided to give you a written statement.

high voltage alert and vehicle shuts down and unable to drive and car locks up Should be recall# 23s53 and NHTSA campaign # 23v-626 It has not been repaired yet and this is very frustrating has happened 4-5 times Last incident happened on 11/7/2025 inside of a car wash & had to get towed

1- ABS/Braking Issue The ABS system appears to be malfunctioning. On multiple occasions, typically once or twice a week, when I apply the brakes, the tires lock up and cause the vehicle to skid. This happens most often when descending hills or backing up on a sloped driveway. The wheels lock and slide until I release the brake pedal, posing a serious safety concern. 2- Severe Water Leak Interior Roof Area There is a significant water leak from the interior roof, specifically from the top center area near the rearview mirror, every time it rains. I’ve taken the vehicle to the dealer multiple times. They confirmed that all drain tubes are clear, all seals are functioning properly, and no water appears to be entering from the sliding moonroof. However, the issue persists. Water pours down like a waterfall through the vent (as shown in the attached photo), soaking the center console and creating an unsafe driving condition. I have also recorded videos showing the water intrusion. Living in Guam, where it rains frequently, this has become a major problem. 3- Malfunctioning Interior Ceiling Light The ceiling light on the driver's side (center dome light) turns on randomly and often remains on until manually switched off. The dealer has inspected this issue but reported no faults found. Despite this, the problem continues to occur intermittently. 4- Rear Camera Display Issue When shifting into reverse, the monitor occasionally turns completely blue, and the backup camera does not function. The blue screen remains until the vehicle is turned off and restarted. This happens sporadically and disrupts safe maneuvering.

Emergency escape issue Like many modern cars the aviator was designed with electric opening doors. Of the four doors, only the front driver side door has a manual override in case of emergency. That means if a major accident was to occur on that ONE door and disable the vehicle the other 3 doors do not have a way to exit. Why would the nhtsa allow a vehicle on a road that at a minimum doesn't have a override for left side and right side or more than one door?

The contact owns a 2022 Lincoln Aviator. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated while driving approximately 50 MPH, the vehicle stalled. The contact was unable to pull over to the side of the road. It was unknown whether a warning light was illuminated. The vehicle failed to restart and was towed to the residence. The dealer was contacted and confirmed that the part for the recall repair was not yet available. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 10,000.

My Aviator was parked with trunk open to load groceries from shopping cart. Must have stepped under bumper such that it triggered the kick sensor to close the tailgate. The problem is, it did NOT detect spouse’s body, did NOT stop the tailgate from closing & as a result, hit him on the head. He jolted out of the way & the tailgate continued to close all the way. This is serious safety issue!

Reference my NHTSA complaint # 11681607 dtd 8/19/25 regarding the problem with Autosense wipers that I’ve had since I bought my Aviator 2.5 yrs ago. As I previously reported, problem was finally resolved in April when dealer replaced the Autosense sensor. I have come to learn that the plastic covering dealer found on the sensor (see attached pic) is actually a protective film for part shipment & should have been removed by the assembly plant prior to installing the sensor but was NOT. There are other owners that have this same ‘wipers gone wild’ condition with Autosense wiping in which the windshield does not clear enough for safe driving & you need to switch to manual wiper operation to clear the windshield. This plant assembly error should trigger a recall with all manufacturers that use this part, not just Lincoln.

Despite multiple backup camera recalls & fixes, the backup camera blurs visibility & engages the backup collision avoidance system when there’s a steady rain thereby preventing me from backing car up my DW & parking in garage. The vehicle repeatedly stops & engages the rear collision avoidance system so much so that I had to turn it off in settings to back my car in. Cleaning the backup camera lense did not improve this condition. It appears the system cannot differentiate between rain & an object.

The AUTOSENSE wiper function has been erratic & not working properly since my Aviator was a yr old (2022). None of the Autosense wiper stalk positions worked correctly to clear the windshield enough for safe visability. I had dealer check this problem 3 times in 2023 & 2024 & they indicated no problem was found & no codes appeared. After experiencing dangerous visability issues on a 4 hr trip in which I needed to keep the regular wiper on to see (because Autosense didn’t clear windshield enough to see on Hwy), I left vehicle at dealer & refused to pick it up until problem was corrected once & for all. Since car is under warranty they decided to replace the sensor & found it to be defective (yellowed). Since replacing the sensor Autosense now works. This leads me to believe these sensors are failing prematurely. I’m posting this in case others are experiencing a similar problem with Autosense wipe.

The contact owns a 2022 Lincoln Aviator. The contact stated that while driving at various speeds, the vehicle hesitated while depressing the accelerator pedal. There was no warning light illuminated. The vehicle was taken to a dealer to be diagnosed, but the cause of the failure could not be determined. Additionally, the contact received notifications of NHTSA Campaign Numbers: 25V407000 (Structure), 25V393000 (Seats), and 25V455000 (Fuel System, Gasoline). The dealer was notified of the recalls and the contact was informed that parts to do the recall repairs were not yet available. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was unknown.

Lincoln Aviators 2020-2024 using the Sync 3 Radio screen. Have a issue not switching to dimmed/night mode during night time driving. This is a major safety issue because when driving a night you have a super bright display inches from your eyes creating a blinding issue at night. This issue has been reported by many folks, a simple Google search will reveal this. Unless NHTSA steps if to doing something 10s of thousands Lincoln Aviators 2020-2024 are on the road with blinded drivers. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Please see the attached email conversations and service records with Lincoln Motor Company (manufacturer) and Kayser Lincoln (service center and dealer) regarding the issues with the display in this vehicle. I have had this vehicle into the service center 50 times in the past 2 years trying to get this display issue fixed - they have not fixed it. I have asked for a vehicle buy back - Lincoln has denied this request. I have filed or a Lemon Law Complaint - Lincoln has denied this request. This is only the first 10 attachments of the 33 attachments I have in evidence - but I can only upload 10.

What component or system failed or malfunctioned, and is it available for inspection upon request? The 2nd row seats have an electrical switch to slide and slightly fold the seat for entry to the 3rd row. This switch seems to get stuck and will randomly slide and tilt the seat forward while driving as well as while stationary. while driving, the seat can hit the back of the driver seat very hard and cause disorientation. The vehicle has not yet been reproduced or inspected by a dealer or other service center. the vehicle has not been inspected by manufacturer, police, insurance rep, or any other organization. There were no warnings or messages prior to failure, this car I purchased used and the symptom was presenter as soon as I drove off the lot.

The contact owns a 2022 Lincoln Aviator. The contact stated that while driving approximately 75 MPH, there was a loud banging sound above the contact’s heads. The contact became aware that the sunroof had fractured into several pieces, leaving a large hole in the sunroof. The vehicle was not taken to the dealer to be inspected or repaired. The manufacturer was not informed of the failure. The failure mileage was 51,000. The VIN was not available.

Driving and slowing down accident brakes and frontal collision and airbags didn't go off

Ford states remedy not yet available.

The contact owns a 2022 Lincoln Aviator. The contact stated that while her husband parked during a car wash, the contact who was seated in the front passenger seat exited the vehicle when it unintendedly accelerated and crashed into a pole. The contact confirmed that the vehicle was still in the park position when it suddenly lunched forward crashing into the pole a second time. In addition, the contact stated that the pre-collision assist with automatic emergency braking system failed to engage. No warning light was illuminated. No injuries were sustained. No police report was filed. The vehicle was taken to the dealer; however, the cause for the failure was not determined. The manufacturer was not notified of the failure. The failure mileage was approximately 34,873.

The car has stopped electrically with no response from any switches when trying to switch on. This has happened before couple of times and once it switched on by itself after 5 min, the second incident it had to be towed away from road after no response in 2 hours. This time it happened like every time and no response from electrical systems and blocked the road.

The contact owns a 2022 Lincoln Aviator. The contact stated while having a routine tire rotation at the dealer, the mechanic stated that the lug nuts were swollen. The contact was informed that the tire rotation could not be performed and there was no recall repair for the failure. The vehicle was not repaired. The manufacturer was contacted but no assistance was provided, and the contact was referred to the NHTSA Hotline. The failure mileage was 25,147.

When vehicle is put into park, you can hear the transmission slam into place as well as feel the car jolt. When vehicle is in park and moved to reverse, the car will delay and then throw into gear moving backwards causing a jolt and increased speed.

The display on our 2022 Lincoln Aviator failed, again. It had been repaired by the dealer with a new rear camera. It failed to show the backup view, again, and also that display shows the controls for defrost and other safety features. It was a rainy day, so, we were without a display screen showing the backup camera AND could not turn on our defroster as it is located on that dark screen, also. Our windows fogged due to no defroster, and, we had no back up camera view to show traffic behind us. We called the dealer and, they said wait for a recall, as one on the software is in the making right now. There was no warning that this would happen. after driving the vehicle and parking and restarting it, the display lit up again.

When starting the car at night, the center display will run at full daytime brightness until the driver manually presses one of the up/down display/interior brightness control buttons. Once pressed, the system "realizes" that it's night time and adjusts accordingly. Having the display at full brightness at night is a safety hazard for drivers unaware that you can use the brightness control buttons as a workaround. My local dealership says this is "normal" behavior.

On 6/9/22 I ran off the road and down a ravine. I hit a large tree head on and hit some smaller trees on the right side of the vehicle. After the head on collision with the large tree, it broke the frame in two places. The car had severe damage on the front and right side as you will notice in the pictures I am sending. No airbags deployed during this collision. I was shocked that none of them deployed after such a hard impact with the front of the car and the right side. The local police and fire department that arrived on the scene were very concerned that the air bags didn’t deploy. The towing company and body shop owner was also very concerned that the airbags didn’t deploy after he examined the car after the accident. I just want everyone to be aware of this safety feature that failed me after I paid $70k for a car with five star safety ratings.

4/19/22 Staten Island NY. As I was getting off of the Hylan Blvd exit from the SI Expressway traveling toward NJ, I made a left turn. While the wheel was turned the power steering failed, locking up the steering wheel. These alerts came on the dashboard: Hill Start Assist Warning, Service Steering, Pre-Collision Assist Not Available. The car was towed to Dana Ford and the technician says that a high voltage fuse burned out. They also stated that they wanted to find the cause for the fuse to burn out before replacing it. This was two weeks ago.

the main "Sync" dashboard screen, 3 different times within 2 weeks, after warm engine was re-started, the screen was looking like video was completely out of "sync" of "vertical hold", mostly vertical, in sections, making the screen unuseable: the vertical image was rolling in the vertical axis. After several to many minutes of driving & re-starting the secreen went back to "normal".

Door ajar notification continues to illuminate when all doors are secure. First incident happened on 1/25/2022. Was sent in for repair and returned on 2/2/2022. Issue happened again while driving on the interstate on 3/10/2022, and is back in for repair. This notification causes domes lights to continue to illuminate which is a danger at night, and will not allow for doors to lock.