2002 MERCEDES-BENZ S-Class Problems & Complaints
Real owner complaints and problems reported to the National Highway Traffic Safety Administration (NHTSA). View common issues by component.
VIN Decoder
133
Complaints Reported
As an Amazon Associate, ForCar.org earns from qualifying purchases.
Complaints by Component
ELECTRICAL SYSTEM
36 complaints
The contact owns a 2002 Mercedes-Benz S500. The contact stated that upon starting the vehicle, the instrument panel and dashboard lights were off. There were no warning lights illuminated. The contact stated that his daughter was able to drive the vehicle since the exterior lights were working properly. The vehicle was taken to the dealer who diagnosed that the instrument cluster had failed and needed to be replaced. The contact stated that the failure had been reoccurring while driving. The contact referenced NHTSA Campaign Number: 06V028000 (Interior Lighting). The manufacturer was notified of the failure and informed the contact that an extended warranty had been issued for the failure but had already expired. The vehicle was not repaired. The approximate failure mileage was 100,000.
Dec 09, 2021
I HAVE APPROXIMATELY 104,000 MILES, I CANNOT SEE IT ANYMORE BECAUSE WHILE DRIVING HOME AT NIGHT FROM THE AIRPORT ON THE EXPRESSWAY DOING 65 MILES PER HOUR, IT WENT BLACK. ALL THE GAUGES WERE FOUND STUCK IN THEIR LOCATION THE NEXT MORNING AT WHAT THEY WERE AT WHEN THE CLUSTER WENT BLACK. THE CLUSTER HAS NEVER RECOVERED AND I HAVE TO DRIVE WITH NO IDEA OF SPEED, SIGNALS OPERATION, FUEL LEVEL, OR WATER TEMP. THE INFORMATION DISPLAY IS ALSO BLANK SO I DON’T KNOW WHAT MY MILEAGE IS OR IF THE VEHICLE HAS ANY OTHER INFORMATION TO GIVE ME. I HAD TO DRIVE HOME 60 MILES IN THE DARK. MY HEADLIGHTS GO ON ALL BY ITSELF WHENEVER I START MY CAR NOW. MY CLIMATE CONTROL ALSO REMAINS LIT AND CAUSES A BATTERY DRAIN OVER A PERIOD OF TIME. I WAS VERY LUCKY TO MAKE IT HOME BUT NOW I CAN ONLY DRIVE DURING THE DAYTIME UNTIL I CAN GET MY INSTRUMENT CLUSTER REPAIRED. MY COMFORT LEVEL DRIVING THIS VEHICLE HAS DIMINISHED GREATLY, THIS VEHICLE IS MY FAMILY VEHICLE, DOES MERCEDES BENZ NOT CARE ANYMORE. IF ONE OF THEIR FAMILY MEMBERS WERE TO PERISH IN AN ACCIDENT AS A RESULT OF THIS PROBLEM I’M PRETTY SURE THEY WOULD IMMEDIATELY FIND A SOLUTION TO FIX IT.
Nov 08, 2018
THE BATTERY LOCATED IN THE TRUNK OF THE VEHICLE IS SITUATED NEXT TO THE GAS TANK. THERE ARE NO COVERS ON THE METAL PARTS ON THE TOP OF THE BATTERY LOCATED IN THE TRUNK OF THE VEHICLE, AND THE MAT THAT COMES WITH THE VEHICLE DOES NOT SUFFICIENTLY COVER THESE METAL POLES, LEAVING THEM VULNERABLE TO CATCH FLAME WHEN METAL ITEMS ARE IN THE BACK OF THE VEHICLE. THE REAR BATTERY CAUGHT FLAME, WHILE STATIONARY, DUE TO A METAL ROD USED FOR FURNITURE ASSEMBLY TOUCHING THE EXPOSED PORTION OF THE BATTERY.
Nov 18, 2017
MY DASH LIGHTS WENT OUT I CAN'T SEE ANYTHING NOT MY SPEED DASH IS DARK NIGHT AND DAY
Mar 21, 2017
WHILE DRIVING ON 12/10/2016, THE INSTRUMENT CLUSTER PANEL WENT VERY DARK. AT NIGHT THERE WAS NO ILLUMINATION EITHER. ALSO THE SPEEDOMETER WAS FLUCTUATING WILDLY FROM HIGH TO LOW AND BACK. I COULD ONLY SEE THIS WITH MY INTERIOR LIGHT ON, AS THE DASH PANEL WAS DARK. I REALIZED I COULD NOT READ ANY OF THE OTHER THE GAUGES INCLUDING THE SAFETY WARNING DISPLAY PANEL, NOR DID THE TURN SIGNALS INSIDE THE VEHICLE WORK OR THE VOLUME CONTROL ON THE STEERING WHEEL. THE VEHICLE WAS IN MOTION AT THE TIME. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 06V028000 (INTERIOR LIGHTING). ON 12/15/16 THE MANUFACTURER WAS NOTIFIED OF MY FAILURE. THE MANUFACTURER INFORMED ME THAT IT WAS NOT A RECALL BUT A "VOLUNTARY EXTENDED WARRANTY ISSUE". THE MANUFACTURER EXPLAINED TO ME THAT MY CAR WAS PART OF IT, BUT I WAS "OUT OF TIME" WITH MY REQUEST FOR REPAIR OR REPLACEMENT. AT THE TIME THE CAR HAD APPROXIMATELY 195,000 ON IT. THIS IS THE 5TH MERCEDES I HAVE OWNED, READING FROM THE BLOGS THIS IS A VERY COMMON PROBLEM, HENCE THE NHTSA INVOLVEMENT. MINE IS A DOCUMENTED FAILED CASE UNDER MERCEDES RECOGNIZED PROGRAM, BUT THEY FAIL TO FOLLOW-UP WITH THEIR EXTENDED WARRANTY COVERAGE BECAUSE IT IS OUT OF TIME. WHETHER IT IS IN TIME OR OUT OF TIME A SAFETY FAILURE IS A SAFETY FAILURE. ONE WOULD THINK THAT A COMPANY LIKE MERCEDES BENZ WOULD WANT TO KEEP ALIVE A 5 TIME OWNER OF MERCEDES AND PUT BRAND LOYALTY OVER PROFIT. I HAVE THREE CHILDREN NOW ENTERING THEIR CAR OWNING YEARS. THEY HAVE GROWN UP WITH MERCEDES BUT I GUESS IT IS NOW TIME TO SHOW THEM ANOTHER CAR BRAND SO THEY CAN BE A CUSTOMER FOR LIFE TO ANOTHER AUTOMOBILE COMPANY, ONE THAT WILL PLACE THEIR LIFE AHEAD OF THE PROFIT ON AN INSTRUMENT CLUSTER. I ASK THE NHTSA TO FORCE MERCEDES TO RECALL THESE SAFETY PRONE CARS SUCH THEY CANNOT HIDE BEHIND THEIR "OUT OF TIME" EXCUSE. *TR
Dec 15, 2016
+ 31 more complaints for this component
SUSPENSION
29 complaints
ABC LINE STARTED LEAKING SECOND TIME IN 4 YEARS EXACTLY REPLACED IT BACK IN 2013 ALMOST COST ME 1500 AND NOW ITS BACK DOING THE SAME PROBLEMS THE CAR IS TO LOW ON THE GROUND AND CAN'T NOT DRIVE WHATS SO EVER
Jul 15, 2017
I PURCHASED MY VEHICLE NEW IN 2002. IT HAS ABOUT 48500 MILES. I WORK CLOSE TO HOME. I HAVE ALREADY REPLACED THE SUSPENSION AIR BAGS ONCE AND MY VEHICLE IS DROPPING AGAIN. I HAVE READ THAT THIS IS A COMMON PROBLEM WITH MY VEHICLE YEAR, MAKE AND MODEL. WHAT CAN I DO? MY VEHICLE IS VERY WELL TAKEN CARE OF AND I FIND IT OUTRAGEOUS THAT MERCEDES BENZ BEING FULLY AWARE OF THIS ISSUE, REFUSES TO TAKE RESPONSIBILITY. ESPECIALLY WITH THE ORIGINAL PRICE OF THE VEHICLE.
Apr 11, 2016
MY AIRMATIC SUSPENSION MADEY MY CAR GO DOWN REAL LOW, I PAY A LOT OF MONEY TO GET THE TWO AIR MATIC SUSPENSION FIX. MY REAR END IS STILL GOING DOWN AND NOW THE REAR IS LOWER THAN THE FRONT. I AM JUST LIJE THE REST OF THE PEOPLE THAT HAS COMPLAINT ABOUT THIS . NHTSA ACTION NUMBER PED7042. I FEEL THEY NEED TO MAKE THE MANUFACTURER FIX THIS PROBLEM BEFORE SOME ONE GET HURT BAD OR DEAD.
Sep 02, 2015
TWICE SINCE I'VE HAD THIS CAR I'VE HAD TO REPLACE THE SUSPENSION FIRST THE BACK THEN AT MY FATHERS FUNERAL THE FRONT BOTH RESULTING IN A LOT OF MONEY, AND THERE IS NO RECALL ON THE SUSPENSION? WHY? *TR
Jun 09, 2014
MY COMPLAINT IS RELATED TO MY 2002 MERCEDES BENZ S500 ABOUT THE AIRMATIC I TOOK MY TOTHE SHOP AND PAY LOT OF MONEY TO GET THE AIRMATIC FIX BECAUSE THEY WHAT SAID THAT WAS IT . THE CAR IS STILL GOING DOWN WHEN IT SIT FOR A DAY OR TWO AND NOW THEY ARE TELL ME THAT IT IS THE SUSPENSION VALVE BLOCK. I BELEIVE THAT I HAVE BE TAKING , BECAUSE I AM A WOMAN. I FEEL SOMETHING SHOULD BE DONE ABOUT THIS. *TR
Mar 21, 2014
+ 24 more complaints for this component
ENGINE AND ENGINE COOLING
8 complaints
RIGHT SIDE CATALYST BROKE APART AND FAILED. IT CAUSED THE CAR TO RUN REALLY HORRIBLE AND STALL OUT MANY TIMES. MANUFACTURER DOESN'T WANT TO BE RESPONSIBLE FOR THE REPAIR, EVEN IF THE VEHICLE ONLY HAS 65000 MILES. IT WON'T PASS THE CALIFORNIA EMISSION TESTING. *TR UPDATED 12/17/14. *JB
Dec 13, 2013
MASSIVE OIL LEAK. I HAVE BEEN TOLD THAT IT'S EVERYTHING FROM OIL PRESSURE VALVES TO THE OIL COOLER. MB... WHAT'S THE PROBLEM?? I NEED HELP AND NONE OF THE SAN DIEGO MB DEALERS CAN FIX PROPERLY. *TR
Nov 10, 2011
OIL LEAK FROM OIL COOLER SEEMS TO BE A CHRONIC PROBLEM ON THIS MODEL CAR. *TR
Dec 05, 2009
IDLE PULLEY (PLASTIC) FAILED/BROKE ON I-68 AT TOP OF SIDELING HILL GAP CAUSING LOSS OF POWER STEERING AND OTHER POWER RELATED ITEMS. CAR HARD TO CONTROL GOING DOWN LONG, STEEP HILL. WHEN PULLEY BROKE, SERPENTINE BELT FELL OFF. WE WERE INFORMED THAT THIS IS NOT AN UNCOMMON PROBLEM. CAR ONLY HAS 53,000 MILES. *TR
Jul 24, 2009
OIL COOLER LEAK ON MY 2002 S600, AND I FOUND OUT THAT THIS A VERY COMMON PROBLEM ON THESE CARS (2000-2002 V12 ENGINES) AND A VERY EXPENSIVE REPAIR THAT MERCEDES BENZ SHOULD COVER OR AT LEAST A LARGE PERCENTAGE OF THE REPAIR. I JUST FOUND OUT ABOUT YOUR WEBSITE SO I DECIDED TO FILE A COMPLAINT. I TOOK THE CAR TO THE MERCEDES BENZ DEALER AND THEY DIAGNOSED IT AND SAID THE REAR MAIN SEAL NEEDED TO BE REPLACED. I PAID OVER $1100.00 FOR THIS REPAIR AND TOOK THE CAR BACK 3 TIMES WITHIN A WEEK AND A HALF BECAUSE THE OIL LEAK CONTINUED ONLY TO FIND OUT THE OIL COOLER IS WHAT IS LEAKING AND NOT THE REAR MAIN SEAL. *TR
Aug 24, 2008
+ 3 more complaints for this component
EXTERIOR LIGHTING
6 complaints
NHTSA RECALL CAMPAIGN NUMBER : 06V028000 INSTRUMENT CLUSTER ON THE DASH BOARD DOES NOT ILLUMINATE MAKING IT UNABLE TO READ THE GAUGES WHILE DRIVING DURING THE DAY OR NIGHT RESULTING IN UNKNOWN SPEEDS AND CREATING UNDESIRABLE SAFETY CONDITIONS. I HAVE CONTACTED MERCEDES BENZ OF GEORGE TOWN TEXAS TODAY MARCH 7 2016 AND THEY REFUSED TO HONOR IT BUT THEY TOLD ME TO BRING IT INTO THE DEALERSHIP WITH $160 DIAGNOSTIC FEE. I CAME HOME ON FRIDAY MARCH 4TH AND WHEN I WENT TO GET BACK INTO THE VEHICLE, I NOTICED THE DASH LIGHTS DID NOT ILLUMINATE. I CAN BE REACHED AT[XXX] 'INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *BF
Mar 07, 2016
TL* THE CONTACT OWNS A 2002 MERCEDES BENZ S430. WHILE DRIVING AT 70 MPH, THE INSTRUMENT PANEL LIGHTS FLICKERED ON AND OFF THEN FAILED TO ILLUMINATE. THE VEHICLE ALSO STARTED TO LOSE POWER. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE INSTRUMENT PANEL CLUSTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 06V028000 (INTERIOR LIGHTING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 151,012.
Oct 09, 2015
INSTRUMENT CLUSTER WENT DARK WHILE DRIVING. SUBSEQUENTLY, FLICKERED ON MOMETARILY A FEW TIMES, NOW IS DARK ALL THE TIME.
Sep 22, 2015
TL* THE CONTACT OWNS A 2002 MERCEDES BENZ S-CLASS. THE CONTACT STATED THAT WHILE DRIVING 60 MPH THE INSTRUMENT PANEL LIGHTS MALFUNCTIONED. THE CONTACT WAS UNABLE TO DETERMINE HOW FAST THE VEHICLE WAS TRAVELING OR DETERMINE ANY OF THE OTHER READINGS ON THE INSTRUMENT PANEL. THE CONTACT REFERENCED NHTSA CAMPAIGN I.D. 06V028000 (INTERIOR LIGHTING) AND CALLED THE MANUFACTURER. THE MANUFACTURER INFORMED THE CONTACT THAT THE RECALL WAS CLOSED DUE TO THE YEAR OF THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 111,000.
Jul 13, 2012
XENON HEADLAMPS BLIND ONCOMING DRIVERS. THEY SHOULD BE BANNED !!!!*AK
May 15, 2002
+ 1 more complaint for this component
ELECTRICAL SYSTEM,EXTERIOR LIGHTING
5 complaints
WHILE DRIVING DURING DAYLIGHT HOURS ON FRIDAY, 6/17/2016, I NOTICED THE INSTRUMENT CLUSTER PANEL WAS VERY DARK. THE CAR WAS NOT DRIVEN AGAIN UNTIL DUSK, ON SATURDAY, 6/18/2016 AND I REALIZED ALL OF THE INSTRUMENT PANEL LIGHTS WERE OUT, THE GAUGES WERE NOT WORKING NOR DID THE TURN SIGNALS INSIDE THE VEHICLE OR THE AUTOMATIC LOCKS, WORK OR THE VOLUME CONTROL ON THE STEERING WHEEL. THE VEHICLE WAS IN MOTION AT THE TIME OF THIS DISCOVERY
Jun 20, 2016
FIRST INCIDENT IN OCTOBER 2013 INSTRUMENT PANEL SUGGESTED THAT REAR LIGHTS WERE MALFUNCTIONING. TOOK IN TO MECHANIC AND REPLACED FUSE, THEN APPROX. 3 WEEK LATER REPEATED MALFUNCTION, BUT NOW THE INSTRUMENT PANEL WENT DARK. REPLACED FUSE AGAIN, AFTER THIS TIME IT LASTED FOR ANOTHER COUPLE OF WEEKS. NOW IT'S DECEMBER 2013 AND THE ENTIRE INSTRUMENT PANEL IS DARK, NO MILEAGE, SPEEDOMETER, FUEL OR SAFETY GAUGES. MECHANIC TOOK ANOTHER LOOK AND ADVISED THAT IT WAS THE INSTRUMENT CLUSTER. I KNOW THERE IS A RECALL ISSUED ON THIS SAFETY ITEM. WOULD LIKE TO GET SOME HELP RESOLVING THIS ISSUE. *TR
Jan 07, 2014
ALL LIGHTING ON INSTRUMENT PANEL BEGAN FLICKERING ON AND OFF ,PANEL REMAINED TOTALLY DARK, NO LIGHTS, NOTHING WORKED ON STEERING WHEEL. I WAS DRIVING ABOUT 50 MPH AND IT WAS DARK. COULD NOT SEE ANY LIGHTING ON GAUGES. TOOK VEHICLE TO DEALER WAS TOLD ABOUT RECALL ON INSTRUMENT CLUSTER .AFTER CHECKING FOUND OUT THAT MY VEHICLE WAS NOT INCLUDED IN RECALL. I FEEL THAT IT SHOULD HAVE BEEN INCLUDED BECAUSE MY VEHICLE HAD ALL INDICATIONS REFERRED TO IN PARTICULAR RECALL OF INSTRUMENT CLUSTER. THIS NEEDS TO BE INVESTIGATED FURTHER. *TR
Apr 29, 2013
INSTRUMENT CLUSTER FAILURE. ALL LIGHTING FOR INSTRUMENT DARK/UNREADABLE (SPEEDOMETER,TACH,ODOMETER,FUEL,TEMP,TURN SIGNAL ETC). TAKEN TO DEALER AND I PAID FOR REBUILD TO UNIT. IDENTICAL FAILURE OCCURED AGAIN AFTER APPROX 3 MONTHS. *TR
Feb 14, 2013
ON STARTING THE VEHICLE, THE INSTRUMENT PANEL WAS BLACK WITHOUT ILLUMINATION OR READING. AS A RESULT, GAUGES TO SPEEDOMETER, ODOMETER, FUEL, WARNINGS TO MALFUNCTIONS, TACHOMETER, OIL PRESSURE, & ENGINE TEMPERATURE ARE NOT PRESENT. *TR
Jun 06, 2012
INTERIOR LIGHTING
4 complaints
The contact owns a 2002 Mercedes-Benz S500. The contact stated that the instrument cluster had started to flicker and had eventually gone completely blank without warning. The contact had taken the vehicle to a dealer where he was informed that his vehicle was not included in NHTSA Campaign Number: 06V028000 (Interior Lighting). The manufacturer was also notified of the failure and provided the contact with the same information as the dealer. The vehicle was not repaired. The failure mileage was approximately 135,000. The defective instrument cluster also prevents the owner of these cars not knowing when the vehicle air shocks can and will suddenly drop without warning like the rear air shocks completely dropped.
Nov 22, 2021
INSTANT FAILURE OF INSTRUMENT CLUSTER. CLUSTER UNDER RECALL #06V028000. WAS CHARGED BY DEALERSHIP. SAID MAKE AND MODEL WERE UNDER RECALL, BUT MY VIN # WAS NOT. *JB
Nov 27, 2006
DT*: THE CONTACT STATED WHILE TRAVELING AT NIGHT, THE DASHBOARD LIGHTS WENT OUT. THE VEHICLE WAS PULLED OVER AND WAS DRIVEN TO THE DEALERSHIP THE NEXT DAY. THE DEALERSHIP REPLACED THE INSTRUMENT CLUSTER MODULE. THERE WAS A NHTSA RECALL #06V028000, REGARDING THE INTERIOR LIGHTING, BUT THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. *AK UPDATED 12/1/20006 - *NM
Oct 23, 2006
INSTRUMENT PANEL HAS FAILED, NO ILLUMINATION. I CAN NOT SEE MY GAUGES. I CONTACTED A LOCAL DEALER AND THEY SAID MY VIN # DOES NOT APPLY TO THE RECALL. IT IS A 2002 MERCEDES BENZ S430. *JB
Oct 06, 2006
POWER TRAIN
4 complaints
WE HAD TO HAVE OUR CAR TOWED FROM INSIDE THE CAR WASH BAY BECAUSE THE CAR WOULD NOT SHIFT OUT OF PARK. THE NEUTRAL SAFETY SWITCH, WHICH IS PLASTIC, BROKE PROHIBITING THE CAR FROM SHIFTING OUT OF PARK. THE TOW TRUCK DRIVER MERCEDES BENZ ROADSIDE SENT TO US TOLD US HE SEES THIS ALL OF THE TIME WITH THIS PARTICULAR CAR. ALSO BY THE FORUMS, YOU CAN SEE THAT THIS IS A PARTICULAR PROBLEM FOR CERTAIN YEARS. FROM WHAT I UNDERSTAND, THE NEW SHIFT BOX FROM MERCEDES HAS AN ALUMINUM SAFETY SWITCH OR "BILLET". WE ATTEMPTED TO BUY THE NEW "BILLET" BUT OUR MERCEDES BENZ DEALER WILL NOT SELL IT TO US. WE WERE TOLD HE HAD TO HAVE THEM TAKE THE ENTIRE THING APART DO THE WORK THEMSELVES FOR CLOSE TO $1000 FOR WHAT SHOULD BE A $00.50 PART. IN ORDER TO GET THE "BILLET" IT HAS TO BE BOUGHT AFTERMARKET ONLINE FOR CLOSE TO $200.00. OBVIOUSLY MERCEDES BENZ KNEW IT WAS AN ISSUE, THEREFORE CHANGING IT FROM PLASTIC TO ALUMINUM, SO THEY SHOULD BE CHANGING ALL PLASTIC ONES FOR FREE. *TR
Jan 07, 2012
TL* THE CONTACT OWNS A 2002 MERCEDES BENZ S55 AMG. THE CONTACT STATED THAT HE WAS UNABLE TO SHIFT THE VEHICLE OUT OF PARK. THE VEHICLE WAS TAKEN TO A LOCAL SHOP WHERE IT WAS DIAGNOSED THAT THE SHIFTER WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 118,000.
Jul 22, 2011
TL*THE CONTACT OWNS A 2002 MERCEDES-BENZ S500. THE CONTACT STATED THAT WHILE TRYING TO SHIFT THE VEHICLE OUT OF PARK THE GEAR SHIFT LOCKED AND WOULD NOT MOVE OUT OF GEAR. THE VEHICLE WAS TOWED TO A DEALER AND STATED THAT THE CONTACT HAD TO REPLACE THE ENTIRE SHIFT MECHANISM. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 48,000.
Nov 16, 2010
I HAVE A 2002 MERCEDES S430. I WOULD LIKE TO REPORT A DEFECTIVE PART ON THIS VEHICLE. THE "ELECTRONIC SHIFTER MECHANISM" WENT BAD ON MY VEHICLE WITH 47,000 MILES ON THE ODOMETER. MY CAR TURNED ON, HOWEVER THE "SHIFTER" WOULD NOT COME OUT OF PARK. IT WAS DETERMINED MY THE MERCEDES SERVICE SHOP THAT THE "ELECTRONIC SHIFTER MECHANISM" WAS BAD. DURING THE COURSE OF WAITING FOR MY VEHICLE TO BE REPAIRED, I HAD RESEARCHED THE ISSUE ONLINE AND THROUGHOUT VARIOUS SOURCES, ESPECIALLY "ONLINE MERCEDES BENZ FORUMS," I FOUND THAT HUNDREDS OF PEOPLE WHOM OWN THE SAME VEHICLE AS ME AS WELL AS OTHER MODELS HAVE HAD THE SAME PROBLEM. I FIND THIS TO BE COMPLETELY UNACCEPTABLE FOR NOT ONLY AN EXPENSIVE CAR, BUT FOR ANY CAR. THIS REPAIR WAS AROUND $1,000.00. IF YOU WOULD LIKE FURTHER INFORMATION SUCH AS INTERNET WEBSITES IN WHICH I READ ABOUT OTHER MERCEDES CAR OWNER'S HAVING THE SAME PROBLEM OR MY INVOICE FOR THE REPAIR, FEEL FREE TO CONTACT ME. THANK YOU FOR YOUR HELP! *TR
Jul 11, 2008
TIRES
4 complaints
WHILE DRIVING ON THE 405 FREEWAY SOUTH IN LA COUNTY, CALIFORNIA MY DRIVER'S SIDE REAR TIRE BLEW OUT ALONG THE SIDEWALLS. THE TIRE BRAND AND MAKE IS CONTINENTAL CONTI-TOURING CONTACT 225/60R16. THE VEHICLE IS A 2002 MERCEDES S430. *JB
Aug 27, 2005
2002 MERCEDES-BENZ S500 EXPERIENCING TIRE BLOW OUTS. *MR THERE WAS A RIGHT REAR GASH IN THE SIDEWALL AND A BULGE HIGH ON THE SIDEWALL NEAR THE REAR OF THE RIM, THE LEFT FRONT TIRE WAS FLAT DUE TO FISSURE IN THE SIDEWALL, THE THIRD TIRE BLEW OUT WHILE DRIVING ON AN INTERSTATE. THE FOURTH TIRE WAS STARTING TO FRAY. (MODEL/S 500) *SCC *JB
Dec 03, 2003
WHILE THE CONSUMER WAS TRAVELING THE REAR PASSENGER SIDE TIRE BLEW OUT, NO SPECIFIC TIRE INFORMATION GIVEN. *YH
Feb 19, 2002
WHILE THE CONSUMER WAS TRAVELING THE REAR PASSENGER SIDE TIRE BLEW OUT, NO SPECIFIC TIRE INFORMATION GIVEN. *YH
Feb 19, 2002
INTERIOR LIGHTING,ELECTRICAL SYSTEM
3 complaints
See attached document for complaint.
Jan 21, 2025
TL* THE CONTACT OWNS A 2002 MERCEDES BENZ S500. THE CONTACT STATED UPON START-UP, THE INSTRUMENT CLUSTER WENT BLANK. THE CONTACT CALLED MERCEDES-BENZ OF LOS ANGELES (1801 S. FIGUEROA ST, LOS ANGELES, CA 90015) WHERE THEY INFORMED HIM TO BRING THE VEHICLE TO THE DEALER TO BE INSPECTED. UPON INVESTIGATION, THE CONTACT LINKED THE FAILURE TO NHTSA CAMPAIGN NUMBER: 06V028000 (INTERIOR LIGHTING) HOWEVER, THE VIN WAS NOT INCLUDED. THE VEHICLE REMAINED IN THE POSSESSION OF THE DEALER AND WAS NOT REPAIRED. THE MANUFACTURER HAD YET TO BE NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000. ## VIN PASSED ## 2002 MERCEDES BENZ S500 ##
Sep 04, 2020
MERCEDES BENZ HAS LISTED A RECALL ON ALL W220 MERCEDES-BENZ VEHICLES. THE RECALL WAS ABOUT THE INSTRUMENT CLUSTER FAILING RESULTING IN THE CLUSTER TO NOT WORK. THE MPH, RPM DOESN'T WORK. NOTHING ON THE CLUSTER WORKS. WHEN I WENT ON MAY 12, 2011 TO THE MERCEDES DEALERSHIP TO GET MY INSTRUMENT CLUSTER FIXED BECAUSE IT WAS RECALLED I SPOKE WITH A LADY AT THE DEALER EXPLAINING MY SITUATION ABOUT THE PART BEING RECALLED AND THAT IT IS DEFECTIVE. SHE ASKED ME TO GIVE HER MY VIN NUMBER. WHEN SHE TYPED IN MY VIN NUMBER, SHE TOLD ME THAT MY CLUSTER IS NOT ELIGIBLE FOR A REPAIR. SHE SAID THE MY VIN NUMBER WAS A "STATUS 9 ISSUE" AND BECAUSE OF THIS, IT VOIDS ALL WARRANTIES NO MATTER WHAT. I SPOKE WITH EVERYONE THERE TYING TO SORT THINGS OUT AND SEE IF I CAN WORK OUT THIS ISSUE. MY 2002 S430 HAS BEEN IN AN ACCIDENT THAT IS WHY IT IS A STATUS 9. BUT THE INSTRUMENT CLUSTER DID NOT FAIL BECAUSE OF THE ACCIDENT. EVEN AFTER THE ACCIDENT THE CLUSTER STILL WORKED FINE WITHOUT ANY SORT OF PROBLEMS WHAT SO EVER FOR ALMOST A MONTH IF I AM NOT MISTAKEN. I STRONGLY BELIEVE THAT MERCEDES SHOULD TAKE ACTION FOR THIS ISSUE NO MATTER WHAT. IF THE PART IS DEFECTIVE, ITS DEFECTIVE. THAT'S IT. THEY SHOULD TAKE RESPONSIBILITY AND REPLACE MY RECALLED CLUSTER FREE OF CHARGE. I WOULD LIKE FOR THE DEALER TO TAKE IN MY VEHICLE AND REPLACE THE DEFECTIVE CLUSTER. A RECALLED PART LIKE THIS SHOULD BE REPLACED EVEN THOUGH A VEHICLE LIKE MINE WAS IN AN ACCIDENT. AND MY CAR WASN'T IN A BAD ACCIDENT AND I HAVE PROOF AND PICTURES TO SHOW THAT IT WAS NOT HIT THAT BAD. I WOULD GREATLY APPRECIATE IF THIS MATTER WOULD BE ATTENDED TO AND I COULD GET MY PART REPLACED. THANKYOU VERY MUCH. *TR
May 14, 2011
SUSPENSION,ENGINE AND ENGINE COOLING
3 complaints
The contact owns a 2002 Mercedes-Benz S600. The contact stated while driving 60 MPH, the active body control warning light illuminated, after which the front suspension lowered to the ground, preventing the vehicle from being driven. The vehicle was towed to the dealer, who diagnosed a failure with the hydro-pneumatic suspension pump and high-pressure hose. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 07V263000 (Suspension, Engine, and Engine Cooling) but the VIN was not included. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 98,000.
Jul 09, 2024
TL*THE CONTACT OWNS A 2002 MERCEDES S500. THE CONTACT STATED THAT THEY HAD TO TAKE THE VEHICLE TO THE DEALER TWICE FOR THE CHECK ENGINE LIGHT AND FOR AN ALIGNMENT IN THE PAST TWO YEARS. THE CONTACT HAD TO REPLACE THE AROMATIC STRUTS ON THE VEHICLE TWICE BECAUSE OF A FAILURE, THE EXHAUST PIPE AND GENERAL RING FOR THE CHECK ENGINE FAILURE. THE CONTACT WAS CONCERNED ABOUT THE SAFETY ISSUE BECAUSE THE VEHICLE STALLED WHICH MADE IT DIFFICULT TO MANEUVER WHEN THE FAILURE OCCURRED. THE FAILURE MILEAGE WAS 53,140 AND THE CURRENT MILEAGE WAS 117,000.
May 02, 2011
I'M THE OWNER OF A 2002 MERCEDES S430 AND HAVING TROUBLE REPAIRING THE RECALLS ON MY VEHICLE. I HAVE CONTACTED MERCEDES DIRECTLY AND THE LOCAL DEALER AND THEY STATED THAT THEIR ARE NO RECALLS ON MY VEHICLE WHEN IN FACT THERE IS. PLEASE HELP ME RESOLVE THIS ISSUE. *TR
Dec 17, 2009
AIR BAGS
3 complaints
TL* THE CONTACT OWNS A 2002 MERCEDES-BENZ S500V. WHILE DRIVING 35 MPH, THE CONTACT'S DAUGHTER HAD THE RIGHT OF WAY ON THEIR GREEN LIGHT. ANOTHER VEHICLE WAS GOING IN THE OPPOSITE DIRECTION RAN THEIR LIGHT AND THEY CRASHED INTO THE CONTACT'S DAUGHTER'S DRIVER SIDE OF THE VEHICLE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT'S DAUGHTER DID NOT SUSTAIN ANY INJURIES. THE PERSON THAT CRASHED INTO THE CONTACT'S DAUGHTER WAS NOT INJURED. THERE WAS NO NEED FOR MEDICAL ATTENTION. A POLICE REPORT WAS MADE. THE VEHICLE WAS TOWED TO LUXURY AUTO PARK (17651 OAK PARK AVE, TINLEY PARK, IL 60477 (708) 444-4445) WHERE THE MECHANICS WERE WAITING ON INSTRUCTIONS ON WHAT TO COMPLETE ON THE VEHICLE. THE CONTACT WOULD HAVE THE VEHICLE TOWED BACK TO THEIR HOME. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 154,000.
Jul 16, 2019
AIR BAG CONTROL UNIT FAILURE. THIS IS AN ELECTRONIC MODULE THAT CONTROLS THE AIR BAG SYSTEM. WHEN THIS UNIT FAILS, THE AIR BAG SYSTEM NO LONGER WILL FUNCTION. I BELIEVE THAT THIS ITEM FAILED PREMATURELY AND SHOULD BE COVERED UNDER SOME WARRANTY OE RECALLED, AS THIS IS A SAFETY ISSUE, AND ONE WOULD NOT EXPECT THIS ITEM TO FAIL AT SUCH LOW MILEAGE. THE COST TO REPLACE IS WELL OVER $1000.00. *TR
Jun 18, 2009
MY CAR IS AN 2002 MERCEDES S430 AIRMATIC SYSTEM FAILURE STRUTS AND PUMP FIRST THE STRUTS FAILED IN NOV 2008 WHICH LOWERS THE CAR ON TOP OF THE TIRES AND MAKES THE CAR UNDRIVEABLE. NOW IN JUNE 2009, THE PUMP FAILED WHICH LOWERED THE CAR ON TOP OF THE TIRES AND MAKES AND CAR UNDRIVEABLE. THIS IS A SERIOUS SAFETY PROBLEM. IF THIS SYSTEM FAILS WHILE DRIVING, THE CAR AND DAMAGE THE TIRES AND CAUSE A BLOW-OUT RESULT IN AN ACCIDENT. THESE FAILURES HAVE BEEN REPORTED BY MANY OWNERS AND HAVE CAUSED INJURIES AND EXTENSIVE COSTS TO OWNERS. EVERYONE CONSIDERS THESE FAILURES TO BE VERY PREMATURE IN THE LIFE OF THE CAR. THIS IS VERY WIDE SPREAD. *TR
Jun 18, 2009
ENGINE
3 complaints
MASSIVE OIL LEAK. OIL COOLER. BACK OF ENGINE.
Jul 11, 2017
TL* THE CONTACT OWNS A 2002 MERCEDES-BENZ S500. WHILE DRIVING 25 MPH, THE VEHICLE HEARD AN ABNORMAL NOISE COMING FROM THE CENTER OF THE VEHICLE. A WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THERE WAS AN ABC HYDRAULIC FLUID LEAK, WHICH WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 86,140.
Mar 07, 2017
TL* THE CONTACT OWNS A 2002 MERCEDES BENZ S55. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THERE WAS AN ABNORMAL NOISE. THE CONTACT DISCOVERED THAT THE ACTIVE BODY CONTROL HOSE HAD BECOME DETACHED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE ACTIVE BODY CONTROL HOSE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,000.
Oct 27, 2014
STRUCTURE
3 complaints
TL* THE CONTACT OWNS A 2002 MERCEDES BENZ S55. THE CONTACT STATED THAT THERE WAS RUST ON ALL FOUR DOORS AND THE UNDERCARRIAGE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.
Jan 06, 2015
WHILE MAKING LEFT OR RIGHT TURNS THE VEHICLE MADE A CRUNCHING NOISE IN THE INTERIOR OF THE VEHICLE. THE VEHICLE HAS BEEN TAKEN TO THE DEALER FOR REPAIRS (MERCEDES BENZ CLK55AMG 2002). *NLM
May 21, 2003
MY 2002 MERCEDES BENZ CLK 430 CABRIOLET (YOUR WEB SITE DOES NOT LIST THIS MODEL OR THE CLK 55) HAS A WARPED REAR SUB-FRAME AND THERE WAS NO INCIDENT TO CAUSE THIS. THE DEALER TOLD ME THE CAR WAS NOT SAFE TO DRIVE AND CHARGED 3000 TO FIX! *NLM
Apr 16, 2003
ELECTRICAL SYSTEM,INTERIOR LIGHTING
2 complaints
TL* THE CONTACT OWNS A 2002 MERCEDES-BENZ S430. THE CONTACT STATED THAT ILLUMINATION OF THE INSTRUMENT CLUSTER WAS INADEQUATE TO SEE THE GAUGES. FLETCHER JONES IMPORTS (7300 W SAHARA AVE, LAS VEGAS, NV 89117, (702) 364-2700) WAS CONTACTED AND INFORMED THE CONTACT THAT THE VEHICLE WARRANTY EXPIRED IN 2012. THE CONTACT WAS INFORMED THAT A DIAGNOSTIC TEST NEEDED TO BE PERFORMED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO TAKE THE VEHICLE TO THE DEALER TO BE DIAGNOSED. THE CONTACT MENTIONED NHTSA CAMPAIGN NUMBER: 06V028000 (INTERIOR LIGHTING) AS A POSSIBLE SOLUTION TO THE FAILURE HOWEVER, THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 209,000.
Dec 02, 2020
THE INSTRUMENT CLUSTER IN THE COMPANY CAR I AM DRIVING WHICH IS A 2002 MERCEDES BENZ MODEL S500 JUST RECENTLY WENT OUT COMPLETELY. I HAVE TAKEN THE CAR IN TO BE REPAIRED AND A NEW FUSE WAS PUT IN AND IT BLEW WITHIN AN HOUR. I HAVE CALLED MERCEDES BENZ DIRECTLY AND THEY SAID THAT THE RECALL 06V028000 DOES NOT APPLY TO ME. I ALSO CALLED THE FLETCHER JONES MOTORCAR DEALERSHIP AND THEY SAID THE SAME THING. BOTH THE DEALERSHIP AND MERCEDES BENZ REFUSE TO REPLACE THE INSTRUMENT CLUSTER MODULES BASED ON THE SAFETY RECALL 06V028000. THE PROBLEM IS I AM UNABLE TO READ THE GAUGES AND INDICATORS, SUCH AS THE SPEEDOMETER, WHICH COULD INCREASE THE RISK OF A CRASH. *TR
Sep 09, 2008
VISIBILITY
2 complaints
2002 MERCEDES S430 HAS A DESIGN FLAW, NON INJURY TYPE BUT IT IS VERY ANNOYING, WINDSHIELD WASHER TANK IS MOUNTED IN A LOCATION WHICH CAUSES THE O RINGS IN THE TANK TO FAIL AND DISCHARGE ALL THE FLUIDS, RETURNED TO DEALER COUPLE OF TIMES, HOWEVER THEY REFUSED TO FIX IT FOR FREE LAST TIME. *NM
Jul 26, 2006
MY DRIVER AND PASSENGER SIDE WINDOW IS DEVELOPING SPOTS. I FOUND THE MANY OWNER OF THIS W220 S-CLASS MERCEDES BENZ HAVE SIMILAR PROBLEMS. DEALER (CALIBER MOTORS) INSPECTED AND INFORMED ME THAT THE WINDOW STARTED TO DE-LAMINATE. SINCE MY BASIC WARRANTY RAN OUT AT 50,000 MILES I HAVE TO PUT UP THE BILL FOR THE REPAIR. MY CAR IS CURRENTLY AT 61K MILES. ONLY 4 YEAR OLD. THE FRONT 2 WINDOW DELAMINATING IS NOT MY FAULT BUT A DEFECTIVE PART. WINDOWS ARE NOT A WEAR ITEM THEREFORE IT SHOULD NOT FAIL OR IN NEED OF REPLACEMENT BEFORE THE LIFE OF THE CAR EXCEPT IN THE CASE OF AN IMPACT. COST OF REPLACEMENT IS SUBSTANTIAL.. COST CAN EXCEED $700 PER WINDOW FOR PARTS AND LABOR. I FEEL THIS IS A DEFECTIVE PART THAT MAY BECOME A VISIBILITY SAFETY ISSUE IF MANUFACTURER REFUSE TO TAKE RESPONSIBILITY TO REPLACE. CAR OWNER MAY MOST LIKELY NOT CHANGE THE WINDOW DUE TO COST ISSUES. *NM
Jul 24, 2006
LATCHES/LOCKS/LINKAGES
2 complaints
DT*: THE CONTACT STATED THE VEHICLE DOOR LATCHES ON BOTH THE DRIVER AND PASSENGER SIDE MALFUNCTIONED TRAPPING THE OCCUPANTS INSIDE. THE CONTACT ESCAPED THE VEHICLE BY USING A CROWBAR TO OPEN THE DOOR FROM THE INSIDE. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THEY ADJUSTED THE LOCKS AND REPLACED THE REGULATOR HOWEVER THIS DID NOT CORRECT THE PROBLEM. THE MANUFACTURER WAS ALERTED.*AK
Mar 22, 2006
1. FAILURE OF DRIVER'S SIDE DOOR AND PASSENGER DOOR TO LOCK OR UNLOCK. 2. FAILURE OF DEALERSHIP TO PERMANENTLY FIX PROBLEM. IT GETS FIXED BUT IT BREAKS DOWN AGAIN. THE DRIVER'S SIDE DOOR MAY WORK; THEN IT MAY NOT WORK; THEN IT MAY WORK. 2. FAILURE OF DEALERSHIP TO PERMANENTLY FIX PROBLEM. IT IS SUPPOSEDLY FIXED WHEN I LEAVE THE DEALERSHIP - BUT IT FAILS AGAIN. IT HAS NOW FAILED AGAIN FOR THE DOOR TO BE UNLOCKED. 3. THE DEALERSHIP CORRECTS THE PROBLEM BUT IT AGAIN FAILS; NOW IT HAS FAILED TO GET DRIVER'S SIDE DOOR DOES NOT OPEN AGAIN AND I HAVE TO PHYSICALLY UNLOCK THE DOOR FOR IT TO OPEN. AND SOMETIME WHEN I AUTOMATICALLY LOCK THE DOOR BY THE TRANSMITTER; ALL THE DOORS EXCEPT MY DRIVER'S SIDE DOOR DOES NOT LOCK. THIS IS DANGEROUS SINCE IF I ENTER THE VEHICLE WITH THE ONE DOOR LEFT UNLACHED - SOMEONE CAN HIDE IN THE BACK OR ALSO IN A CRASH MY DOOR MAY OPEN UP SINCE I CANNOT LOCK THE DOOR. *JB
Jan 17, 2005
SUSPENSION,ENGINE
1 complaint
ABC high pressure hose blew off while driving at low speed made a loud popping sound abc light came on with message drive carefully and fluid came pouring out
Dec 01, 2023
SUSPENSION,ELECTRICAL SYSTEM,ELECTRONIC STABILITY CONTROL (ESC)
1 complaint
INSTRUMENT LIGHTS WENT OUT, CAN'T SEE SPEED OR OTHER DASH INFORMATION SUCH AS FUEL. REAR SUSPENSION LOOSES AIR, CAR SITS TO LOW TO DRIVE, BODY SITS ON REAR TIRES. HAPPENED WHILE DRIVING CITY STREET, TIRES SMOKED AND ARE PITTED.
Sep 12, 2018
VEHICLE SPEED CONTROL
1 complaint
AFTER OWNING MY USED CAR INSURANCE HAD TO REPLACE THE CLUSTER. FOUND OUT LATER IT WAS ON A RECALL LIST.
Apr 08, 2016
EXTERIOR LIGHTING,VISIBILITY
1 complaint
TL* THE CONTACT OWNS A 2002 MERCEDES BENZ S430. THE CONTACT STATED THAT THE INSTRUMENT PANEL AND THE HIGH AND LOW BEAMS FAILED TO OPERATE. IN ADDITION, THE WINDSHIELD WIPERS WOULD ACTIVATE SPORADICALLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 06V028000 (INTERIOR LIGHTING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.
Oct 17, 2014
SUSPENSION,ELECTRICAL SYSTEM
1 complaint
TL* THE CONTACT OWNS A 2002 MERCEDES BENZ S430. THE CONTACT STATED THAT WHEN DRIVING AT NIGHT, THE INTERIOR, THE INTERIOR, AND THE INSTRUMENT PANEL FAILED TO ILLUMINATE. IN ADDITION, THE CONTACT STATED THAT THE AIRMATIC SHOCKS DROPPED CAUSING THE VEHICLE TO BECOME LOW AND DIFFICULT TO TURN THE WHEELS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 185,000.
Sep 16, 2014
SUSPENSION,POWER TRAIN,ELECTRICAL SYSTEM,STRUCTURE
1 complaint
THE GEAR SHIFTER HAD LOCKED INITIALLY OUT OF THE BLUE, I COULDN'T GET THE CAR OUT OF DRIVE. I TURNED IT OFF TO STOP IT AND THEN IT WOULDN'T GO INTO PARK. AFTER THE MERCEDES TECH CAME OUT IT WOULDN'T START AT ALL. THE TECH SAID IT WAS MOST LIKELY A SAFETY FEATURE WHICH HAD KICKED IN. THEN THE WHOLE RIGHT SIDE WENT DOWN. I AM TOLD THE AIRMATIC SUSPENSION WENT OUT. WHY? THE CAR SAID STOP AIRMATIC TO LOW. I HAVE NEVER HAD ANY PROBLEMS WHICH MAY HAVE LEAD UP TO THESE ISSUES. UNFORTUNATELY I CAN NOT AFFORD THE $2,000 TO REPAIR THIS ISSUE WITH THE AIRMATIC. IS THERE ANY KIND OF RECALL ON THIS VEHICLE OR WARRANTY WITH MERCEDES THAT IS RESPONSIBLE. THE ELECTRICAL PROBLEM IS THE RADIO GOING OUT FOR 2-3 MONTHS AND THEN COMING BACK ON OUT OF THE BLUE. THE DOOR OPEN SIGNAL NOT GOING OFF IN THE ALERTS. THE TRUNK SWITCH NOT WORKING TO OPEN THE TRUNK, IT CAN ONLY BE OPENED MANUALLY. LASTLY THE HEADLIGHTS CONTINUALLY GOING OUT AFTER REPLACING THE BULB FOR 1 MONTH. RUST AND DETERIORATION ON THE ROOF BY THE SUNROOF. *TR
May 12, 2012
SUSPENSION,ELECTRICAL SYSTEM,EQUIPMENT
1 complaint
I OWNED 2002 MERCEDES MODEL S430. ABOUT 6 MONTHS AGO I NOTICED MY CAR DROPPED LOWER TO THE TIRES AS I STARTED, THEN I TURN IT OFF AND BACK ON FOR THE CAR TO FUNCTION NORMALLY. NOW, FOR PAST 2 WEEKS THE PROBLEM HAS COME BACK AND ACTED VERY OFTEN. I ALSO TALKED TO FEW FRIENDS AND THEY SAID OTHER VEHICLES WITH SAME MODEL ARE EXPERIENCING SAME PROBLEM. IS THIS A RECALL FROM MERCEDES TO CORRECT THE PROBLEM YET. I LIKE TO KNOW A LITTLE BIT MORE INFO ON THIS PROBLEM AND HOW TO CORRECT IT. *TR
Feb 16, 2011
UNKNOWN OR OTHER
1 complaint
ATTORNEY REQUESTS CERTIFIED COPIES OF RECALLS APPLICABLE TO 2002 MERCEDES BENZ S500V *TGW
Sep 01, 2010
SUSPENSION,EQUIPMENT
1 complaint
I HAVE A 2002 430S MERCEDES BENZ WITH ONLY 69,000 MILES ON IT. I HAVE REPLACED THE AIRMATIC PUMP AND PAID $641.89 ON SEPT 25, 2008 AT RICK HILL IMPORTS IN KINGSPORT TN AND MY CAR IS AGAIN LOWERING TO THE GROUND WHILE DRIVING SPEEDS OF 40 TO 50 MPH. I HAVE TO PULL OFF THE ROAD TO AIR MY CAR UP WHICH IS DANGEROUS. I TOOK IT BACK TO RICK HILL IMPORTS THEY TELL ME THE SHOCKS ARE LEAKING AIR AND THAT IS A COMMON PROBLEM WITH THESE CARS. I HAVE STARTED DOING RESEARCH ONLINE I HAVE FOUND THAT THEIR ARE SEVERAL ISSUES WITH THIS CAR YR MAKE AND MODEL. I AM TOLD THAT I WILL HAVE TO SPEND ANOTHER 3000-4000 TO GET MY CAR IN THE RUNNING CONDITION IT NEEDS TO BE IN. MY CAR HAS NOT BEEN DRIVEN HARD OR THAT MUCH. THE YR OF MY CAR SHOULD HAVE ABOUT 100000 MILE ON IT, AND IT DOES NOT. I ALSO FOUND WHERE THERE IS AN INVESTIGATION ALREADY IN PLACE FOR THE AIRMATIC SYSTEM. I HAVE MADE MERCEDES AWARE OF MY PROBLEM THEY REFUSE TO DO ANYTHING ABOUT IT. I FEEL THAT I HAVE DEFAULTY SYSTEM AND I WANT THEM TO REPLACE IT AFTER ALL THEY ARE KNOWN FOR EXPENSE LUXURY DEPENDABLE CARS AND THAT IS WHY YOU PAY 70,000 DOLLARS FOR THEIR CARS. THIS LEMON AIRMATIC SYSTEM IS GOING TO CAUSE ME OR ONE OF MY FAMILY MEMBER TO GET KILLED LOWERING TO THE GROUND AT SPEED OF 40-50MPH AND PULLING OFF THE SIDE OF THE ROAD TO LET IT AIR UP. *TR
Jun 20, 2009
AIR BAGS,EQUIPMENT,UNKNOWN OR OTHER
1 complaint
AIR BAG BLEW UP WITH OUT CRASH ABOUT MARCH 2008, MY CAR WAS PARKED IN MY HOUSE DRIVEWAY OVERNIGHT NEXT DAY I WAS GETTING READY TO GO TO WORK WHEN I STEPPED OUT SIDE MY HOUSE AND I FOUND MY AIR BAGS HAD BLOWN UP. MERCEDEZ BENZ DEALER AT LONG BEACH, CALIFORNIA SEND A MECHANIC TECHNICIAN AND HE WORK ON THE VEHICLE TRYING TO START THE VEHICLE SO I CAN DRIVE TO THE DEALER AND HE COULD NOT START THE VEHICLE, SO THEY TOWED THE VEHICLE AWAY TO THE DEALER, THEY BEEN FIGURING OUT WHAT WAS THE REASON FOR THE AIR BAG TO BLEW UP, UJP TODAY DATE JUNE 11, 2008 THEY SAID THAT IT'S MY PROBLEM AND I SHOULD PAY FOR THE DAMAGE, AND I BELIEVE THAT THIS IS A MANUFACTURING MALFUNCTIONS. PLEASE HELP ME I DO NOT WHAT TO DO. *TR
Jun 11, 2008
VISIBILITY,EQUIPMENT,ELECTRICAL SYSTEM
1 complaint
TL*THE CONTACT OWNS A 2002 MERCEDES BENZ S500. ON OCTOBER 1, 2007, THE MILEAGE GAUGE DISPLAYED 26,700. THE FOLLOWING DAY, THE GAUGE DISPLAYED 43,000. EVER SINCE THE VEHICLE WAS PURCHASED IN 2005, THE WINDOWS AND SUNROOF HAVE OPENED WITHOUT WARNING WHILE DRIVING AT SPEEDS RANGING FROM 20 TO 45MPH. THE FAILURE OCCURRED WHILE DRIVING THROUGH A CAR WASH AND WHILE PARKED WITH THE ENGINE SHUT OFF. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURES. THE CONTACT STATED THAT THE CD PLAYER FAILED A FEW WEEKS AGO AND THE DEALER INFORMED HER THAT IT NEEDED REPLACING. THERE WAS A WARNING LIGHT THAT INDICATED NO MALFUNCTION, HOWEVER, AFTER THE DEALER DIAGNOSED THE FAILURE, IT BEGAN TO DISPLAY MESSAGES. SHE WAS INFORMED BY A MECHANIC THAT THE FAILURES WERE ELECTRICAL. THE CONTACT IS THE ONLY DRIVER OF THE VEHICLE. THE CORRECT CURRENT MILEAGE WAS 26,700 AND FAILURE MILEAGE WAS 8,500. *UPDATED 12/12/07 *BF UPDATED 12/12/07 *TR
Oct 02, 2007
ELECTRONIC STABILITY CONTROL
1 complaint
RECEIVED RECALL FROM MERCEDES BENZ #2007-060002. HAD JUST HAD THIS CONDITION FIXED BY DEALERSHIP AT MY COST. DEALERSHIP SAID THAT CONDITION WAS NOT RELATED AND REFUSED TO REIMBURSE ME FOR MY COST. I ASKED FOR REPLACEMENT PART # TO BE EMAILED TO ME. I HAVEN'T RECEIVED IT YET.I FEEL THAT THE CONDITION WAS RELATED TO RECALL AND SHOULD BE REIMBURSED BY DEALER PURSUANT TO LAW 49 U.S.C CHAPTER 301. *TR
Jul 10, 2007
POWER TRAIN,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL
1 complaint
DT: THE CONTACT STATED WHEN PRESSING THE ACCELERATOR PEDAL THERE WAS A THREE SECOND DELAY. THE VEHICLE WOULD ACCELERATE SUDDENLY. THE DELAY PROGRESSIVELY BECAME WORSE WHILE DRIVING AND EVENTUALLY THE VEHICLE WOULD NOT RESPOND AT ALL. THE DEALERSHIP DETERMINED THE GAS PEDAL NEEDED TO BE REPLACED. THE VEHICLE LOCKED IN PARK; IT WAS TOWED TO THE DEALERSHIP. THE DEALERSHIP REPLACED THE GEAR SELECTOR HOUSING. *AK THE GEAR WOULD NOT COME OUT OF PARK. UPDATED 021/21/06. *JB
Jan 12, 2006
SERVICE BRAKES, HYDRAULIC,AIR BAGS,SEAT BELTS,STRUCTURE,EQUIPMENT
1 complaint
CONSUMER STATED HE PURCHASED A LEMON. SINCE PURCHASING THE VEHICLE IT HAS BEEN IN THE REPAIR SHOP 4-5 TIMES AND EACH TIME AT LEAST A MONTH. THE AIR BAG LIGHT CAME ON AND WENT OFF INTERMITTENTLY. WHEN THE CONSUMER TOOK THE VEHICLE TO THE REPAIR SHOP THE AIR BAG LIGHT WENT OFF AND DID NOT COME BACK ON, THE DOORS WOULD NOT OPEN AND THE AIR CONDITIONER MALFUNCTIONED. THE MECHANIC WAS UNABLE TO RESOLVE THE PROBLEMS. THE VEHICLE WAS UNSAFE TO DRIVE. *AK THE DRIVER'S SEAT BELT WAS PROBLEMATIC, THE CIGARETTE LIGHTERS IN THE REAR DOORS WERE INOPERATIVE, THERE WAS A HESITATION UPON ACCELERATION, THE LEFT FRONT LOW BEAM LIGHT WOULD COME ON THE DISPLAY, THE VOICE OPERATION WAS HARD TO HEAR ON BOTH RECEIVING AND ANSWERING, THE BRAKES FELT SOFT, THE TRUNK SPRINGS WERE BROKEN AND WOULD NOT OPEN PROPERLY, THE CELL PHONE WAS INOPERATIVE, AND THE CHECK ENGINE LIGHT HAD COME ON. (MODEL/S500) *SC *JB
Jun 29, 2004
AIR BAGS,EQUIPMENT
1 complaint
DEPLOYED AIRBAGS INJURE 2 PA. FIREFIGHTERS DAVE SOMMERS, STAFF WRITER APRIL 24, 2003 EDGELY, PA. FIREFIGHTERS FACE A LOT OF HAZARDS EVERY TIME THEY SUIT UP. BUT THEY DON'T EXPECT TO BE STRUCK BY AUTOMOBILE AIRBAGS SUCH AS WHAT OCCURRED ON TUESDAY WHEN EDGELY FIRE COMPANY FIREFIGHTERS RESPONDED TO A CAR FIRE IN THE 3M INDUSTRIAL PARK IN BRISTOL TOWNSHIP. IN FACT, OFFICIALS SAID ANDY TAGGART, 25, WAS KNOCKED OUT WHEN THE DRIVER-SIDE AIRBAG ON A 2002 MERCEDES BENZ INEXPLICABLY DEPLOYED AS THE VETERAN FIREFIGHTER WAS CHECKING THE DASH FOR DAMAGE. A SECOND FIREFIGHTER, RYAN FLANAGAN, 18, WAS SLIGHTLY INJURED WHEN HE WAS STRUCK IN THE HEAD BY A PARTIALLY DEPLOYING AIRBAG AS HE WAS CHECKING THE RIGHT SIDE OF THE FRONT DASH, OFFICIALS SAID. BOTH WERE RUSHED TO ST. MARY MEDICAL CENTER IN LANGHORNE WHERE THEY WERE KEPT FOR OBSERVATION AND THEN RELEASED EARLY YESTERDAY. FLANAGAN SAID EDGELY RESPONDED TO THE FIRE SCENE AROUND 9:38 P.M. AFTER LEARNING THAT A 2002 MERCEDES BENZ WAS ON FIRE IN FRONT OF A&Z AUTOMOTIVE ON MANNING BOULEVARD. WHEN FIREFIGHTERS ARRIVED, THEY SAW SMOKE COMING FROM UNDER THE DASH AND BEGAN TO GET THE SITUATION UNDER CONTROL. THE DRIVER SIDE AIRBAG BLEW WITH SUCH FORCE IT KNOCKED TAGGART UNCONSCIOUS WHILE THE PASSENGER SIDE BAG, WHICH ONLY PARTIALLY DEPLOYED, STRUCK A GLANCING BLOW OFF THE SIDE OF RYAN FLANAGAN'S HEAD. BOTH FIREFIGHTERS WERE WEARING HELMETS, WHICH LIKELY SAVED THEM FROM FURTHER INJURY. AEROSTAR, THE SECURITY COMPANY WHICH ELECTRONICALLY MONITORS LUXURY CARS SUCH AS THE MERCEDES, HAD AUTOMATICALLY CALLED 911 WHEN IT DETECTED A FIRE UNDER THE DASHBOARD. THE AEROSTAR SYSTEM ALSO AUTOMATICALLY UNLOCKED THE CARS DOORS AND CONTACTED THE OWNER, WHO WAS NOT WITH THE VEHICLE AT THE TIME. THE FIRE INSIDE THE MERCEDES WAS EXTINGUISHED BEFORE IT COULD CAUSE MUCH DAMAGE. *NLM
Apr 26, 2003
ELECTRICAL SYSTEM,EQUIPMENT
1 complaint
THE VEHICLE WAS EQUIPPED WITH A SAFETY FEATURE WHICH AUTOMATICALLY REDUCES THE SPEED OF THE VEHICLE TO 20-30 MPH WHEN VARIOUS SENSORS DETECT SOME SORT OF MECHANICAL DIFFICULTY. WHILE THE CONSUMER WAS DRIVING ABOUT 60 MPH THE SAFETY FEATURE ACTIVATED AND THE VEHICLE SPEED WAS REDUCED. THE DRIVER WAS FORCED TO PULL OVER AND THE VEHICLE WAS TOWED TOT HE DEALER. I WAS LATER DETERMINED THAT A FAULTY ESP CONTROL MODULE SENT A FALSE WARNING TO THE SYSTEM THAT MADE THE VEHICLE REDUCE SPEED. THE CONSUMER FEELS THIS FEATURE WAS DESIGNED POORLY AND THAT IT SHOULD BE DESIGNED SO IT COULD BE MANUALLY OVERRIDDEN (MERCEDES BENZ S430 2002). *MR *SCC *NLM
Apr 22, 2003
Frequently Asked Questions
How many problems does the 2002 MERCEDES-BENZ S-Class have?
The 2002 MERCEDES-BENZ S-Class currently has 133 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.
What are the most common problems with 2002 MERCEDES-BENZ S-Class?
The most common problems reported for the 2002 MERCEDES-BENZ S-Class are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.
Where does this 2002 MERCEDES-BENZ S-Class problem data come from?
All problem and complaint data for the 2002 MERCEDES-BENZ S-Class comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.
Other Years - MERCEDES-BENZ S-Class Problems
2025
2024
2023
2022
2021
2020
2019
2018
2017
2016
2015
2014
2013
2012
2011
2010
2009
2008
2007
2006
2005
2004
2003
2001
2000
Other MERCEDES-BENZ Models
Similar Brands
ST
3,555 models
RS
3,484 models
NC
2,822 models
ND
2,385 models
Z
1,951 models
MOTO
1,583 models
NU
1,189 models
RC
1,122 models