2004 TOYOTA Highlander Recalls

VIN Decoder

Premium Report

Recalls Found

Radar Detector GPS Tracker OBD2 Scanner Car Refrigerator Jump Starter Dash Cam

As an Amazon Associate, ForCar.org earns from qualifying purchases.

All Recalls

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.

NHTSA 11V539000

Report Date

09/11/2011

Component

ENGINE AND ENGINE COOLING

Manufacturer

Toyota Motor Engineering & Manufacturing

Consequence: IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.

Remedy / Corrective Action

TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.

NHTSA 11V112000

Report Date

24/02/2011

Component

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

Manufacturer

TOYOTA MOTOR NORTH AMERICA, INC.

Consequence: IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.

Remedy / Corrective Action

DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

ON CERTAIN SPORT UTILITY AND HYBRID VEHICLES, THE TWO RETAINING CLIPS FOR THE DRIVER'S SIDE FORWARD CENTER CONSOLE CAN BECOME LOOSE. IF BOTH CLIPS SEPARATE FROM THE FLOOR CARPET COVER, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL, CAUSING INTERFERENCE WITH THE ACCELERATOR PEDAL ROD.

NHTSA 06V253000

Report Date

13/07/2006

Component

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

Manufacturer

TOYOTA MOTOR NORTH AMERICA, INC.

Consequence: THIS CONDITION MAY INTERFERE WITH THE ACCELERATOR PEDAL RETURNING TO THE IDLE POSITION INCREASING THE RISK OF A CRASH.

Remedy / Corrective Action

DEALERS WILL REPLACE THE TWO FLOOR CARPET COVER RETAINING CLIPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 24, 2006, AND SHOULD BE COMPLETED BY EARLY SEPTEMBER 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.

NHTSA 10V499000

Report Date

21/10/2010

Component

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

Manufacturer

TOYOTA MOTOR NORTH AMERICA, INC.

Consequence: A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.

Remedy / Corrective Action

DEALERS WILL REPLACE THE SEAL WITH A NEWLY DESIGNED ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.

CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION.

NHTSA 04V181000

Report Date

15/04/2004

Component

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Manufacturer

TOYOTA MOTOR NORTH AMERICA, INC.

Consequence: THIS CONDITION COULD ALLOW THE DOOR TO BE OPENED WITH THE INSIDE WHILE THE OPERATOR BELIEVES THAT THE CPL WAS ACTIVATED. IF THE DOOR WERE OPENED FROM THE INSIDE WHILE THE VEHICLE WAS IN MOTION, AN OCCUPANT COULD FALL OUT AND BE INJURED.

Remedy / Corrective Action

DEALERS WILL SHORTEN THE CPL LEVER. OWNER NOTIFICATION BEGAN MAY 7, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.

4.9/5.0

84 reviews

Where to Find VIN for Recall Check

To check for recalls on your 2004 TOYOTA Highlander, you'll need the VIN number. Find your VIN in one of these 4 common locations.

Where to Find VIN Number on 2004 TOYOTA Highlander for Recall Lookup - Dashboard, Door Jamb, Engine Bay, Documents

Understanding VIN Structure for Recall Verification

Each character in your 2004 TOYOTA Highlander 17-digit VIN helps identify specific recalls affecting your vehicle. Learn how the VIN structure works for accurate recall lookup.

2004 TOYOTA Highlander VIN Structure for Recall Verification - WMI, VDS, Check Digit, Model Year, Plant Code

How to Check 2004 TOYOTA Highlander Recalls in 3 Steps

Locate Your VIN

Find the 17-character VIN on your 2004 TOYOTA Highlander dashboard (visible through windshield), door jamb, engine bay, or vehicle documents.

Enter VIN in Checker

Input your VIN into our free recall checker tool above to search NHTSA database for safety recalls, TSBs, and service campaigns specific to your vehicle.

Review & Schedule Repair

Check the recall details including affected components, consequences, and remedy. Contact your TOYOTA dealer to schedule free recall repair appointment.

Frequently Asked Questions

How many recalls does the 2004 TOYOTA Highlander have?

The 2004 TOYOTA Highlander currently has 5 recalls according to NHTSA records. All recall information is sourced directly from the National Highway Traffic Safety Administration database.

Are 2004 TOYOTA Highlander recalls free to fix?

Yes! All safety recalls for 2004 TOYOTA Highlander vehicles must be repaired free of charge by authorized dealers, regardless of vehicle age or mileage. Contact your local TOYOTA dealer to schedule a recall repair.

How do I check if my 2004 TOYOTA Highlander has open recalls?

You can check for open recalls by entering your VIN (Vehicle Identification Number) in our VIN decoder tool. The 17-character VIN can be found on your vehicle registration, insurance card, or on the driver's side dashboard visible through the windshield.

Where can I find my 2004 TOYOTA Highlander VIN number?

Your 2004 TOYOTA Highlander VIN is located in 4 places: (1) Dashboard near windshield on driver's side, (2) Driver's door jamb sticker, (3) Engine bay, (4) Vehicle registration and insurance documents.

What should I do if my 2004 TOYOTA Highlander has a recall?

Contact your nearest TOYOTA dealership immediately to schedule a free recall repair. Bring your vehicle registration or VIN number. All safety recalls must be fixed free of charge by the manufacturer, regardless of vehicle age or mileage.

Are NHTSA recalls mandatory to fix on 2004 TOYOTA Highlander?

While not legally required for vehicle owners to fix recalls, it's strongly recommended for safety. However, dealerships and manufacturers must offer free repairs for all official NHTSA recalls on 2004 TOYOTA Highlander vehicles.