How many problems does the 2016 TOYOTA Highlander have?

The 2016 TOYOTA Highlander currently has 106 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2016 TOYOTA Highlander?

The most common problems reported for the 2016 TOYOTA Highlander are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

2016 TOYOTA Highlander Problems

UNKNOWN OR OTHER

16 complaints

While driving down the road the panoramic moonroof section of the sunroof exploded. This included a lout shotgun like sound. The sound, in addition to not having sufficient roof coverage, resulted in a safety issue. Glass shards may have also been thrown to vehicles behind us. The dealer is closed today, but I will be contacting them in the morning to report the issue and to see if it is covered. I understand that this happens relatively frequently, but no recall has been issued. I have reached out to insurance and will likely be filing a claim if Toyota doesn't cover it. No party has inspected at this point. There was no warning to this.

Jun 05, 2022

UNKNOWN please investigate this vehicle. The recalls we're never addressed. The dealership I purchased the car from, AutoNation Honda Roseville refused to service this car after a maintenance required warning light and tire pressure warning light came on and gasoline averaging 9mpg I complained about on 1-5-2022

Jan 08, 2022

After shopping, we went to open the trunk of our Highlander by pressing the button. As it opened, we heard a crunching sound from the top but the trunk continued to open. It then reached the point where suddenly the top spoiler was dislodged and the back window's glass exploded outward in a thousand small pieces all over my husband. At no point did a safety mechanism turn on to stop the trunk from opening. We had a few prior experiences with the trunk failing to stop if something was in its way, demonstrating that there is an issue with the sensor or there is no sensory system in the car that would prevent it from crushing something or someone. After contacting Toyota, they stated that this was not covered under the warranty of the vehicle.

Nov 11, 2021

HAS THERE BEEN ANY RECALLS IN MY VEHICLE THAT I HAVEN'T ADDRESSED OR TAKEN CARE OF? I AM ON THE ROAD QUITE A BIT AND WAS NOTED OF SEVERAL PAST RECALLS. THANK YOU . [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Sep 20, 2020

MY SUV S SUNROOF SHATTERED WHILE DRIVING ON A SUBURBAN STREET WITH TWO KIDS IN CAR SEATS BEHIND ME . IT SOUNDED LIKE AN EXPLOSION . GLASS IS ALL OVER THE CAR , IT HAS TO BE TOWED AND I NEED A RENTAL CAR AND I HAVE TO FILE A CLAIM FOR MY INSURANCE NOW.

Sep 19, 2020

+ 11 more complaints for this component

SERVICE BRAKES

13 complaints

The contact owned a 2016 Toyota Highlander. The contact stated that while driving at an undisclosed low speeds on a decline, the brake pedal depressed all the way to the floorboard. As a result, the vehicle rolled downhill into a busy intersection and was struck by another vehicle on the passenger side door. The air bags did not deploy. No warning lights were illuminated. The vehicle was towed to a tow yard and deemed at total lose by the contacts insurance provider. A police report was filed with no injuries reported. The manufacturer was notified of the failure; a case was opened, and the contact was referred to the NHTSA hotline for assistance. The failure mileage was 62,000.

Dec 02, 2024

Crash: 1

2 years ago I pulled my car, that was backed into the driveway out to turn it around to face in to the garage. As I pulled forward going very slowly I pressed on the brakes and the rubber pad on the pedal came off and caused my foot to come off of the pedal. I hit my wife's car and caused some slight damage to my car and to hers. I contacted Toyota and they had my car inspected and gave me a report that the brakes worked fine. I have not replaced the rubber pad, because I am afraid the cover will come off again in a similar matter. I explained this to Toyota but they closed the case of my complaint. I believe this is a danger that can cause an accident.

Jun 16, 2022

Crash: 1

I'VE HAD TWO SERIOUS INCIDENTS INVOLVING THE CAR'S AUTO BRAKING SYSTEM WE BOUGHT AS PART OF A SAFETY PACKAGE. BOTH WERE IDENTICAL. EACH TIME I WAS DRIVING ON A MAJOR HIGHWAY AND THE CAR DETECTED A POTENTIAL SIDE IMPACT CRASH. BOTH TIMES, I SAW THE HAZARD IN TIME AND GIVEN THE CLOSE PROXIMITY OF TRAFFIC BEHIND BE AND THE HIGH RATE OF TRAFFIC FLOW SPEED I DETERMINED MY BEST CHANCE AT AVOIDING THE CRASH WAS TO ACCELERATE PAST THE SIDE IMPACT HAZARD. THE CAR DISAGREED AND SLAMMED ON THE BRAKES. THIS CAUSED ME TO ALMOST LOSE CONTROL OF THE CAR BECAUSE MY SPEED BOTH TIMES WAS >70 MPH. AND IT WOULD HAVE CAUSED A SERIOUS MULTI-CAR COLLISION FROM BEHIND. THE FIRST TIME IT OCCURRED I WENT STRAIGHT TO A TOYOTA DEALER AND ASKED HOW TO 'TURN OFF' THE SYSTEM. THEY SAID THEY CAN'T WITHOUT DISMANTLING EVERY ASPECT OF THE CAR'S SAFETY FEATURES. AFTER WATCHING ANOTHER TOYOTA GO THROUGH WHAT I BELIEVE WAS A SIMILAR INCIDENT WHILE DRIVING THROUGH A TUNNEL RECENTLY, I AGAIN VISITED A TOYOTA. THEY SEEMED INTERESTED IN THE COMPLAINT BUT HAD NO IDEAS FOR ME AS TO WHAT TO DO ABOUT IT. SAID THEY'D RECEIVED NO OTHER COMPLAINTS, WHICH I FIND DIFFICULT TO BELIEVE.

Oct 30, 2019

BRAKES DID NOT WORK AND CAR WENT THROUGH A 4 WAY STOP SIGN. DATES WENT OUT: SEPTEMBER 2019, OCTOBER 2019. BRAKES FAILED ON A NORMAL DAY DRIVING UNDER 30 MPH IN RESIDENTIAL AREA.

Sep 24, 2019

AT LOW SPEEDS SUCH AS SLOWING FOR A STOP SIGN VEHICLE RANDOMLY BRAKES BY ITSELF WITH SUDDEN STOPPING OF VEHICLE. OCCUPANTS AND ITEMS IN VEHICLE ARE THROWN FORWARD. NORMAL BRAKE PRESSURE APPLIED. HAS HAPPENED TO BOTH MYSELF AND MY WIFE WHILE DRIVING. VEHICLE HAS BEEN TO SHOP MULTIPLE TIMES INCLUDING 1 REPLACEMENT OF 12V BATTERY AS A SOLUTION, HOWEVER VEHICLE CONTINUES TO HAVE ISSUES. LISTED DATE IS APPROXIMATE OF ORIGINAL OCCURRENCE. SOME INSTANCES CAPTURED ON DASH-CAM VIDEO.

Aug 18, 2019

+ 8 more complaints for this component

ELECTRICAL SYSTEM

8 complaints

Description of Problem (electrical issue affecting multiple systems): Engine shuts off while driving. All instrument/electronic displays shut off or flicker while driving. Steering wheel locks and vibrates. Liftgate does not open. Vehicle cannot be unlocked with fob. Vehicle does not start. May start after several attempts. Safety: My family's safety was put at risk when car stalled and almost hit by other vehicles while driving on streets and highway. Risk has continued because Toyota has not identified and fixed the problem. Dealer: The problem has been reproduced by dealer. Dealer blamed and replaced battery, but problem continued. Vehicle only inspected by dealer and nobody else. Warning Lamps/Message: No Service lights or warning messaged on.

Mar 16, 2023

I had bought my vehicle 5 months ago in an authorized Toyota dealer, on Easter Day we got on the vehicle drove 15 minutes from home to the park, parked my vehicle, turn it off and went to the park are next to where my vehicle was parked, from where i was sitting i was able to see my vehicle and we wasn't that far, not even 5 minutes after that i walked near the vehicle and notice it was on fire. No light was on in the dashboard, everything was working fine, the vehicle just had an oil change at the begging March 2022 and now in April 2022 it caught fire. This was my dream vehicle and i worked hard to get it. Fire fighters arrived at the scene, police department as well, the police gave me a report number, also a fire department investigator was called to the scene where he certified it was a short circuit and gave me a report number as well.

Apr 25, 2022

Fire: 1

THE LIFTGATE HIT MY 73 YEAR OLD MOTHER IN THE HEAD KNOCKING HER BACKWARDS WITHOUT ANY SAFETY FEATURE STOPPING OR REVERSING THE DOOR AS IT CLOSED.

Jan 29, 2020

Injuries: 1

VEHICLE PRE-COLLISION SYSTEM ACTIVATING RANDOMLY WITH NO OTHER VEHICLES NEARBY. DASH DISPLAY LIGHTS UP WITH WARNING ACCOMPANIED WITH RAPID BEEPING WHILE DRIVING. MULTIPLE TIMES NOTED ON VIDEO FROM DASH-CAM. HAS COME ON WHILE CHANGING LANES AND CAN CAUSE AN ACCIDENT BY THE DISTRACTION. HAS HAPPENED ON FREEWAY AS WELL AS CITY DRIVING. WHILE COASTING AND ACCELERATING. DATE LISTED BELOW IS APPROXIMATE.

Aug 18, 2019

TWO SEPARATE ISSUES: 1. RAIN SENSING WIPERS ACTIVATE RANDOMLY ON CLEAR DAYS, SUN SHINING. WIPERS WILL WIPE ON TIME WHILE DRIVING RANDOMLY. A SEVERE DISTRACTION. 2. CRUISE CONTROL DISPLAY ACTIVATING RANDOMLY WHILE DRIVING WITH NO VEHICLES NEARBY IN FRONT (ACTIVE CRUISE CONTROL VEHICLE). DISPLAY WILL BE NORMAL AND THEN GO BACK AND FORTH THE THE SET DISPLAY SCREEN. DISTRACTING WHILE DRIVING ON FREEWAY.

Aug 18, 2019

+ 3 more complaints for this component

VISIBILITY/WIPER

6 complaints

The side view mirrors are positioned in a way that completely blocks visibility on the sides of the car, especially when making a left-hand turn. After owing the vehicle for several weeks, I collided with another car when making a left-hand turn. I couldn't see the car when turning until it was too late. I've been driving for 30+ years and have never had an accident before. I had another close call several weeks ago, and my husband almost didn't see a pedestrian because of the visibility issue. I looked up the problem online and see that many other have had this same problem. Please look into it. I called Toyota but they don't have a recall and said they couldn't help. I plan to change out my side view mirrors but wanted to bring this to your attention so that no one gets hurt by this issue. Thank you.

Nov 06, 2023

Crash: 1

I was driving and I started to lower my sun visor and something broke and visor went all the way down and I could not see and had to pull over and remove the visor from the arm. I have been told Toyota had a problem before but they are not willing to fix the problem ( they should replace the whole sun visor.

Feb 02, 2022

DRIVING SOUTH ON 12/20/2017, ON US-287 NEAR THE OKLAHOMA/TEXAS BORDER WITH NO OTHER VEHICLES VISIBLE IN FRONT OF US OR ONCOMING TRAFFIC, THE FRONT SECTION OF OUR SUNROOF SUDDENLY EXPLODED. LUCKILY THE SHADE WAS DRAWN OR SMALL PIECES OF GLASS WOULD HAVE FALLEN DOWN ON MY FAMILY. THE WEATHER WAS CLEAR AND NEARLY CLOUDLESS BLUE SKY DAY. DEALER REFUSED TO REPLACE UNDER WARRANTY THEY SAID IT HAD TO HAVE BEEN A ROCK. THEY OFFERED NO PROOF THAT IT WAS A ROCK AND I FIND IT NEXT TO IMPOSSIBLE THAT IT COULD HAVE BEEN CAUSED BY ANYTHING ELSE. WHILE DRIVING WE DID HAVE A FAIRLY DRASTIC TEMPERATURE CHANGE FROM THE MID 20'S TO THE MID 60'S. WE WERE DRIVING STRAIGHT AT HIGHWAY SPEEDS.

Jan 02, 2018

THE BULKY SIDE MIRRORS ON THE TOYOTA HIGHLANDER BLOCK THE DRIVER'S VIEW OF ONCOMING TRAFFIC WHEN MAKING A LEFT HAND TURN. I HAVE ON AT LEAST THREE OCCASIONS BARELY MISSED A COLLISION BECAUSE OF VISIBILITY ISSUES RELATED TO THE BULKY SIDE WINDOW ON THE DRIVER'S SIDE. MY ELDERLY AUNT DRIVING A 2017 TOYOTA HIGHLANDER WAS RECENTLY INVOLVED IN A SERIOUS COLLISION BECAUSE OF VISIBILITY ISSUES RELATED TO THE BULKY SIDE MIRROR, I WILL LET HER FILE HER OWN COMPLAINT

Dec 14, 2017

SINCE APRIL WE HAVE BEEN TRYING TO GET OUR WINDSHIELD REPLACED. THE LOCAL AUTO GLASS DEALER BROUGHT OUT 3 SEPARATE WINDSHIELDS THAT DIDN'T FIT BEFORE THE FINALLY DISCLOSED THAT THE WINDSHIELD WE NEEDED HAS BEEN ON BACK ORDER FOR SOME TIME. APPARENTLY THERE ARE SEVERAL HUNDRED ON BACK ORDER IN OUR REGION AND THE NUMBER SEEMS TO GROW AT A RATE OF ABOUT 15 A WEEK. WE HAVE CONTACTED TOYOTA AND THE DEALER WITH NEITHER ARE OFFERING A SOLUTION. DUE TO THE SLOPE OF THE HOOD, THE SLOPE OF THE WINDSHIELD, OR FAULTY GLASS, THESE CARS SEEM TO BE MORE PRONE TO CRACKS. WITH OUR CAR HAVING 4 CRACKS DEVELOP IN LESS THAN A YEAR WITH MAINLY HIGHWAY AND NO GRAVEL DRIVING, PLUS THE BACK ORDER RATE, THERE SEEMS TO BE A BROADER PROBLEM

Jul 24, 2017

+ 1 more complaint for this component

EXTERIOR LIGHTING

6 complaints

The tail lights on the back tailgate hatch are leaking and have been leaking. The leaks are getting progressively worse and the lights are filling up with water. The vehicle has been garage kept, has low mileage, and has never been wrecked. I feel like this is a manufacturer defect.

Jul 20, 2022

Rear passenger tail light lift gate has water inside tail light housing, if this continues it will cause brake light to be burned off or malfunction and cause vehicle behind these cars unable to see the tail light and cause an accident. The problem has been seen all over toyota forum and a quick google search will provide adequate evidence or recurring problem with this vehicle and similar vehicle with the same tail light manufacturer. Some people has brought their car to the dealerships under warranty for the same issue. I thought these will resolve itself but it has not. So I'm submitting request for recall to solve these problem since removing the housing is a difficult task and might cause more electrical problems.

Feb 20, 2022

WATER INSIDE LEFT TAILLIGHT ASSEMBLY AS PURCHASED USED FROM DAVE EDWARDS TOYOTA, AS CERTIFIED PRE-OWNED

Aug 31, 2020

WHEN DRIVING AT NIGHT ON DARK, HILLY ROADS, THE HEADLIGHTS DO NOT ILLUMINATE THE ROAD PROPERLY. IT IS AS IF THE LIGHTS ARE MASKED HORIZONTALLY WITH THE TOP HALF DARK. IT IS EXTREMELY SCARY TO BE DRIVING ON DARK COUNTRY ROADS THAT ARE HILLY. WHEN YOU ARE TRAVELING DOWN HILL, YOU CANNOT SEE ANY DISTANCE IN FRONT OF THE CAR. GOING UPHILL IS ALMOST AS BAD. IT IS ALMOST ENOUGH TO GET RID OF THIS CAR. SUPPOSEDLY THIS IS TO KEEP FROM BLINDING ONCOMING CARS. I DON'T BUY IT! THIS HAS HAPPENED MULTIPLE TIMES WHEN WE HAVE BEEN TRAVELING TO STATE AND NATIONAL PARKS AND SMALLER TOWNS IN SOUTHERN MISSOURI, TENNESSEE AND NORTH CAROLINA. THE LAST OCCURRENCE WAS MAY 4TH 2018 LEAVING BRYSON CITY NORTH CAROLINA AT 9:30PM.

May 17, 2018

THE REAR PASSENGER TAIL LENS CONTINUES TO FOG UP. I CHECKED TO SEE IF THERE IS A RECALL AND THERE IS NOT. I WOULD LIKE THE LENS REPLACED WHILE STILL UNDER WARRANT. BUT I DON'T WANT ANY ISSUES FROM THE LOCAL DEALERSHIP. HOW DO I RESOLVE THE ISSUE, DO YOU ISSUE A WORK ORDER TO THE DEALERSHIP?

Mar 16, 2018

+ 1 more complaint for this component

TIRES

5 complaints

**Nature of Safety Defect Within 13,000 miles of normal mixed highway and light off-road use on a Toyota Highland, one tire developed a sidewall bubble and all four tires exhibited extreme and uneven tread wear—far below the advertised 50,000-mile treadwear warranty. The remaining tread depth on all four tires is already under 2/32" in multiple locations, with severe cupping and feathering that makes the vehicle vibrate violently above 50 mph and causes unpredictable handling, especially in wet & snowconditions. These conditions render the tires objectively dangerous and unfit for continued highway or street use. Manufacturer Response Pirelli warranty claim #2194927 was summarily denied as “impact damage” with no physical inspection. Pirelli has refused any prorated adjustment, replacement, or refund, and has kept possession of the failed tire. On November 17, 2025, Pirelli Consumer Affairs closed the case stating: “Pirelli considers this claim to be closed and will not take any further action regarding the claim or the subject tires.” Request to NHTSA I am asking the National Highway Traffic Safety Administration to open a formal defect investigation into the Pirelli Scorpion All Terrain Plus line for: Premature and excessive tread wear (tires effectively worn out in under 13,000 miles vs. 50,000-mile rating) Widespread reports of sidewall bubbles and sudden structural failures Potential violation of Federal Motor Vehicle Safety Standards relating to tire strength, endurance, and treadwear labeling (49 CFR Part 571.139 and Part 575) These tires present a clear safety hazard—severe uneven wear and structural defects can lead to loss of vehicle control, hydroplaning, or catastrophic blowouts. Hundreds of owners have posted identical failures online in the past 18–24 months. Please investigate this tire model for possible safety recall or enforcement action. I am happy to provide the tires, in

Nov 20, 2025

P245/55R19 103T Nitto Crosstek2 BW. Vehicle pulls to different directions when the tires are cross swapped. I have taken the vehicle to 4 to 5 wheel alignments within 3 months and 3 different shops after the purchase of the tire. Recently I took the vehicle Big O Tires and they _verified the tires have "Radial Pull" / Tire Conicity due to Manufacturing Defect of the a belt separation within the tire's structure. _The shop also verified that the alignment is performed correctly. I believe those tire are unsafe and they could fail suddenly causing crash.

Aug 15, 2025

The contact owns a 2016 Toyota Highlander equipped with Cooper Tires, Tire Line: Evolution H/T, Tire Size: 245/55/R19, DOT Number: UPPIILE. The contact stated that while his wife was driving approximately 55-65 MPH, the rear driver's side tire unexpectedly had a blowout. The contact's wife pulled over to the side of the road. The contact arrived on the scene and replaced the rear driver's side tire with the spare tire. The vehicle was taken to a tire retailer, where it was determined that the tire blowout was caused by a road hazard. The tire was not replaced. The tire manufacturer was made aware of the failure. The tire failure mileage was 30,000. The vehicle failure mileage was 61,000. The VIN was unavailable.

Jan 13, 2025

Cooper Adventurer P245/60R18 tires. Three of four tires had sidewall separation on both inner and outer sidewalls in same area. A separation could be seen in the outer casing about .25" above the rim line radiating and following the rim line. Tires were also exhibiting constant minor air leakage through the sidewalls. Testing indicated no punctures in the tread areas of the tires. Tires were inspected and found defective and replaced by tire dealer. Dealer took photos of the tires and one was retained for further inspection.

Jun 06, 2022

LEFT REAR TIRE ON OUR 2016 TOYOTA HIGHLANDER BEGIN TO LOOSE AIR WHILE PASSING A SEMI TRUCK ON THE INTERSTATE HIGHWAY. THE TIRE PRESSURE ALARM NOTIFIED THE DRIVER OF TIRE PRESSURE LOSS FOR AN EMERGENCY STOP. UPON A COMPLETE STOP THE TIRE PRESSURE HAD DROPPED ABOUT 85 % OR SO, (NOT FLAT BUT VERY NEAR SO AND COMPLETED THE AIR LOSS WITHIN A SHORT TIME AFTER STOPPING).. WE KNOW THIS BECAUSE I WAS FOLLOWING BEHIND MY WIFE DRIVING THE HIGHLANDER AT THE TIME. TRAVEL SPEED WAS BETWEEN 65 AND 70 MPH AT THE TIME. THE TIRES ARE THE ORIGINAL THAT CAME ON THE TOYOTA NEW AND HAD ABOUT 27000 MILES ON THEM. UPON INSPECTION OF THE TIRE IT LOOKS OBVIOUS THAT THE TIRE WAS DEFECTIVE DUE TO THE SUBSTANTIAL AMOUNT OF VISUAL CRUMBLED RUBBER ALL INSIDE THE TIRE SEPARATED FROM THE SIDEWALLS IN SIDE AND THE MASSIVE BLISTERS ON THE OUTSIDE OF THE TIRE, WE HAD ALL THE TIRES REPLACED ON THE VEHICLE AS WE HAD NO TRUST IN THE REST OF THE TIRES AFTER THIS HAPPENED. NEITHER THE TOYO TIRE MANUFACTURER REP., THE LOCAL TOYOTA DEALERSHIP, OR THE TOYOTA COMPANY WOULD TAKE RESPONSIBILITY FOR THE FAILURE, OR OFFERED ANY CONCESSIONS AGAINST THE REPLACEMENT TIRES. PHOTOS OF THE TIRE AND OR THE TIRE ITSELF IS AVAILABLE FOR NHTSA IF THERE IS A REQUEST TO REVIEW. POOR CUSTOMER SERVICE FROM THE TOYO TIRE MANUFACTURER, THE LOCAL DEALERSHIP OR THE TOYOTA COMPANY IS QUITE OBVIOUS TO US THAT THEY HAD NO CONCERN FOR OTHER PEOPLE THAT MAY HAVE THE SAME TOYO TIRES THAT TOYOTA CHOOSE TO PUT ON THE NEW VEHICLE THAT MAY CAUSE AN ACCIDENT. THE TIRE BRAND IS TOYO, TIRE LINE IS OPEN COUNTRY, TIRE SIZE 245-55-19 DOT # 73HH (CND2216)

Apr 17, 2018

ENGINE

5 complaints

The water pump on my 2016 Toyota Highlander XLE disintegrated while I was driving in heavy traffic. The pulley came loose from the water pump shaft. I have the water pump. Our safety was at risk because this happen in heavy traffic and it could have effected my control of the vehicle if it had came off completely. The pulley was wedge between the wheel well and fame. I sent a claim to Toyota and it was rejected due to the vehicle be out of warranty. I'm saying this is a manufacturing defect. No warning before it happen.

Dec 16, 2024

ENGINE IS MAKING A AUDIBLE KNOCKING SOUND THAT INCREASES WITH ENGINE RPM. THE SOUND IS EMITTING FROM THE BOTTOM RIGHT HAND SIDE OF THE ENGINE (UNDERNEATH/TO THE RIGHT OF THE OIL PAN ON THE SIDE NEAREST TO THE PULLEYS AND SERPENTINE BELT). I HAVE REPORTED THIS ISSUE TO RELIABLE TOYOTA IN SPRINGFIELD MISSOURI. DEALER CLAIMS THE SOUND IS NORMAL EVEN AFTER VIDEO EVIDENCE WAS PROVIDED. HOWEVER, I HAVE NOT HEARD A KNOCKING SOUND COMING FROM OTHER HIGHLANDERS. A NON DEALER MECHANIC WAS CONSULTED AND HE HEARD TO NOISE AND ADVISED MY TO RETURN TO THE DEALER SO THEY MAY SOLVE THE ISSUE UNDER WARRANTY,

Apr 04, 2021

CRANKSHAFT POSITION SENSOR INOPERATIVE DURING NORMAL USE

Dec 11, 2020

WHISTLING/SQUEAKING NOISE FROM ENGINE WHEN TURNED OFF AFTER DRIVING. TOOK A VIDEO AND SHOWED DEALER WHO THOUGHT IT WAS UNUSUAL BUT NO DIAGNOSIS ON MULTIPLE VISITS.

Aug 18, 2019

WHENEVER THE WEATHER IS COLDER LIKE 35 DEGREES OR LOWER I AM HAVING ISSUES STARTING THE VEHICLE. THE DEALER ALREADY CHANGED THE BATTERY BUT IT DID NOT HELP. I HAD THE VEHICLE BY THE DEALER FOR 10 DAYS BUT THEY COULDN'T FIGURE IT OUT. IN THIS TIME I HAD TO PAY OUT OF POCKET FOR RENTAL AND OTHER EXPENSES. YESTERDAY IT TOOK ME 45 MINUTES UNTIL I WAS ABLE TO START THE VEHICLE. I SPOKE TO TOYOTA AND THEY ARE NOT VERY HELPFUL.

Jan 19, 2018

AIR BAGS

5 complaints

TAKATA RECALL'DASHBOARD AIRBAG ICON WILL NOT RRSET

Apr 25, 2019

TAKATA RECALL.

Mar 03, 2017

I HAD AN ACCIDENT ON MY CAR GOING 50 TO 60 MPH I THE ROAD CURVED AND I DID NOT I WENT INTO THE TOP OF THE DITCH HIT FRONT END AND WENT AIRBORN 30 TO 50 FEET IN THE AIR OVER THE PERSONS DRIVWAY. I LANDED ON MY BACK BUMPER WHICH THEN PROPELLED ME BACK INTO THE AIR AND I FLIPPED END OVER END LANDED ON MY TIRES. NOT ONE OF THE AIRBAGS DEPLOYED IN THIS ACCIDENT. THE OFFICER AT THE SCENE WAS SHOCKED. I HIT MY HEAD ON THE STEERING WHEEL THE HEAD REST BROKE I HET IT SO HARD AND THE B PILLAR OF THE CAR. I WAS ON A HIGHWAY.

Oct 29, 2016

Crash: 1

Injuries: 1

I OWN A 2016 HIGHLANDER LIMITED PLATINUM AND AFTER A MAJOR ACCIDENT I HAVE A SERIOUS CONCERN ABOUT THE SAFETY CLAIMS. YESTERDAY MY WIFE WAS IN A ROLLOVER (2 FULL ROTATIONS) ACCIDENT IN HER 2016 HIGHLANDER PLATINUM. CAR WAS DESTROYED, HER HEAD HIT BOTH THE STEERING WHEEL AND THE B-PILLAR, BOTH HAVE AIRBAGS. NOT A SINGLE AIRBAG WAS DEPLOYED. DRIVER AND FRONT PASSENGER SEAT-MOUNTED SIDE AIRBAGS, DRIVER KNEE AIRBAG, FRONT PASSENGER SEAT-CUSHION AIRBAG AND ALL-ROW ROLL-SENSING SIDE CURTAIN AIRBAGS = ALL A TOTAL FAIL, NONE OF THAT WORKED. THE ONSTAR LADY DID HOWEVER SENSE THE ACCIDENT AND DISPATCH AN AMBULANCE AND POLICE, THAT WAS EXCELLENT. WHATEVER CAR I GET AS A REPLACEMENT WILL DEFIANTLY HAVE THAT. NOT REAL HAPPY ABOUT THE SAFETY ON THIS VEHICLE. ONE OF THE REASONS THAT WE PURCHASED THIS VEHICLE WAS THE IIHS RATING ON THE VEHICLE. RIGHT ON THERE SITE IT TALKS ABOUT THE SAFETY AND THE AIRBAG ROLL SYSTEM BUT THE REALITY IS IN A ROLLOVER THIS DID NOT WORK I WILL HAVE THE ACCIDENT SCENE PICTURE LATER TODAY. I CURRENTLY ONLY HAVE SOME OF THE VEHICLE AFTER IT WAS TOWED.

Oct 24, 2016

Crash: 1

Injuries: 2

AIRBAGS DEPLOYED DURING AN ACCIDENT WHERE THE 2016 HIGHLANDER HIT THE REAR OF THE CAR IN FRONT OF IT THAT HAD SLOWED FOR A TRAFFIC LIGHT. THIS ACCIDENT HAPPENED ON 1-25-16 AND THE CAR WAS TRANSPORTED TO A TOYOTA AUTO BODY SHOP ON THE 26TH. SINCE THEN HIGHLANDER HAS BEEN TOTALLY REPAIRED EXCEPT FOR THE SIDE AIRBAGS. TOYOTA MOTOR IN CA HAS NO IDEA WHEN AIRBAGS WILL BE RELEASED FOR USE IN PARTS ON 2016 MODEL. IT IS NOW 3/21/16.

Mar 21, 2016

Crash: 1

ELECTRONIC STABILITY CONTROL (ESC)

4 complaints

WHEN DRIVING, PERIODICALLY, UNDER NO PARTICULAR ROAD OR WEATHER CONDITION, THE "CHECK AWD SYSTEM," "ABS," "BRAKE" AND "STABILITY CONTROL" WARNING LIGHTS LIGHT UP. WHEN WARNING LIGHTS ARE ON, ONLY THE FRONT WHEELS WILL DRIVE AND STABILITY CONTROL IS INACTIVE. REAL WHEELS ARE NOT ACTIVE. THIS CONDITION MAY LAST FIVE TO TEN MINUTES, THEN RETURN TO NORMAL. THIS HAS OCCURRED 10 TO 15 TIMES IN THE LAST SIX MONTHS.

Sep 12, 2019

TRACTION CONTROL SYSTEM ACTIVATES RANDOMLY WHILE DRIVING ON SMOOTH ROADWAY, DRY ROADS. DRIVING DOWN ROAD AND TCS LIGHT FLASHES IN INSTRUMENT CLUSTER.

Aug 18, 2019

COMPLAINT FILES 3/18/2019 COMPLAINT # 11189699 ALL WHEEL DRIVE SYSTEM FAILS IN WET WEATHER. SNOW OR SLUSH OR HEAVY RAIN. FAILURE 7 TIMES. RESETS ITSELF WHEN WEATHER DRY. SENSOR IS CRACKED OR FAULTY. DEALER SAYS OWNER COST. IT SEEMS A TOYOTA FACTORY DEFECT AND SEVERE SAFETY ISSUE. HAPPENS WHEN DRIVING IN SEVERE WEATHER AND MOUNTAIN PASSES IN COLORADO. PLEASE ADVISE

May 21, 2019

TWICE THE AWD SYSTEM HAS FAILED. 12/28/2016 AND MARCH 17/ 2019. THE CHECK ENGINE LIGHT COMES ON THE THE 4WD SHUTS DOWN ALONG WITH THE TRAC AND VEHICLE STABILITY SYSTEM. UNDER BOTH TIMES THE CAR WAS BEING OPERATED IN EXTREME WEATHER CONDITIONS OF DEEP HEAVY SNOW, SLUSH, ICE AND MUD. THE VEHICLE WILL NOT ALLOW THE WHEELS TO SPINS ENABLING ME TO KEEP MOVING IN THE HAZARDOUS CONDITIONS. I NEEDED TO SHIFT BETWEEN 1, 2 AND 3 GEARS TO ENGAGE THE HIGHER REVS TO SPINS THE TIRE TO KEEP THE CAR FROM GETTING STUCK OR SLIDING OFF THE ROAD. IN BOTH INSTANCES I WAS IN REMOTE, ISOLATED AREAS WITH NO HELP AND NO CELL SERVICE. THE DECEMBER 2016 INSTANCES WAS REPAIRED BY A TOYOTA DEALER IN OMAHA. DEALER COULD NOT READILY UNDERSTAND HOW THE PROBLEM INITIATED.

Mar 18, 2019

STRUCTURE

3 complaints

The driver side rear passenger door can not be opened,either by remote or manually. This poses a threat to the safety of passengers in the rear seat area in the event of a crash. First responders would need to take other measures to tend to any injured passengers.

Aug 24, 2024

DRIVING ON HIGHWAY AND SUNROOF EXPLODED. SOUNDED LIKE A GUN SHOT.

Nov 15, 2022

I LOADED A KAYAK THAT IS ABOUT 13' LONG AND WEIGHS 60 LBS. ONTO MY TOYOTA FACTORY CROSSBARS. WHEN DRIVING ON THE FREEWAY WE HEARD CRACKING AND POPPING NOISES. THINKING IT WAS THE STRAPS IN THE WIND, I PULLED OVER ONLY TO FIND THE STRAPS SECURE. WE WERE ON A TRIP AND KEPT GOING. AFTER HEARING THE NOISE ON AND OFF WE GOT TO OUR DESTINATION AND FOUND A WARPED ROOF AND DENTS IN THE ROOF. THIS SHOULD NOT HAPPEN TO A ROOF OF A VEHICLE. I WOULD EXPECT THE CROSS BARS TO FAIL BEFORE THAT WOULD HAPPEN. AFTER A FEW ATTEMPTS, TOYOTA FINALLY HAD AN AREA REP. LOOK AT IT. THEY OFFERED TO HAVE PAINLESS DENT REMOVAL OR $1,000 OFF OF ANOTHER TOYOTA. I DIDN'T WANT EITHER OPTION. THE PDR WOULD HAVE DONE NOTHING AND THE DAMAGE WOULD COME RIGHT BACK. THEY WERE NOT BELIEVING ME THAT CARRYING A LOAD ON THE CROSSBARS DID THAT. WELL, I SWEPT IT UNDER THE RUG FOR A FEW MONTHS AND THIS FALL I HAD TO CARRY A 2X10 BOARDS ON TOP AND AGAIN, WITH FREEWAY SPEEDS DID IT AGAIN. NOW AT CHRISTMAS TIME, WE CUT A TREE DOWN AND LOADED IT ON TOP AND AGAIN, MORE NOISES AND NOW THERE IS MORE DAMAGE THAN THE FIRST PICTURES I TOOK THE FIRST TIME IT HAPPENED AND THE CREASES AND DENTS ARE DEEPER. SOMETHING IS STRUCTURALLY NOT RIGHT WITH MY 16' TOYOTA HIGHLANDER AND TOYOTA WILL DO NOTHING TO HELP. I'M OUT OF OPTIONS AND I HOPE SOMEONE AT NHTSA CAN HELP! I HAVE A $40K SUV THAT I CONSIDER A LEMON. (SEE ATTACHED FOR MORE INFORMATION AND MY ATTEMPTS TO ASK TOYOTA FOR HELP) THANKS! [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB

Dec 20, 2017

ELECTRICAL SYSTEM,ENGINE

3 complaints

2016 toyota highlander le model v-6 cylinder. The FUEL PUMP runs after engine has been turned off for several hours, even up to as many as 8 hours. This situation can be heard in a closed in garage, in the completely quiet of night time, and at multiple times during the same time period. It happens intermittently with various levels of gas in the tank. The length of time FUEL PUMP can run can be as little as 10 minutes to over 60 minutes.

Dec 26, 2023

The contact owns a 2016 Toyota Highlander. The contact stated that while driving at various speeds, the vehicle would shut-off without warning. The contact would be able to restart the vehicle a few minutes after the failure. The contact had taken the vehicle to an unknown dealer. The dealer attempted to charge him a diagnostic fee and the contact refused. The manufacturer had been notified of the failure and they sided with the dealer and insisted that he pay a diagnostic fee to have the vehicle serviced. The vehicle was not repaired. The failure mileage was unknown.

Jul 13, 2021

MY CAR ENGINE STARTED ON ITS OWN AFTER BEING TURNED OFF. I WENT SHOPPING AT WALMART AND PARKED MY 2016 TOYOTA HIGHLANDER XLE IN THE PARKING LOT. I PUT THE CAR IN PARK AND PUSHED THE ENGINE START/STOP BUTTON TO TURN OFF THE CAR. MY FAMILY AND I EXITED THE CAR AND I USED THE KEYLESS ENTRY PAD TO LOCK THE DOORS. WE SHOPPED FOR APPROXIMATELY 45 MIN. WHEN WE RETURNED TO THE CAR, I USED THE KEYLESS ENTRY PAD TO UNLOCK THE DOORS SO I COULD PUT OUR PURCHASES IN THE TRUNK. AS I GOT CLOSE TO THE VEHICLE I HEARD AN ENGINE RUNNING, BUT THOUGHT IT WAS THE CAR NEXT TO US. I BENT DOWN AND LISTENED UNDER THE FRONT END OF MY HIGHLANDER AND TO MY SURPRISE, I REALIZED MY CAR ENGINE WAS RUNNING. WHEN I OPENED THE DRIVER SIDE DOOR AND LOOKED AT THE DASHBOARD, I NOTICED A SMALL TRIANGULAR YELLOW CAUTION LIGHT WAS FLASHING BUT I DON'T REMEMBER WHAT THE MESSAGE SAID OTHER THAN CAUTION. IF MY CAR RANDOMLY STARTS ON ITS OWN WHILE ITS IN A GARAGE, IT COULD CAUSE TOXIC FUMES TO FILL MY GARAGE IF LEFT ON LONG ENOUGH, AND COULD CAUSE HARM OR DEATH TO SOMEONE WHO BREATHES IT IN. AFTER READING ABOUT THE BRAKE/HYDRAULIC RECALL ON SOME 2015-2016 HIGHLANDERS, COUPLED WITH THE RECENT ISSUE I HAD AT WALMART, I AM NERVOUS ABOUT DRIVING MY CAR. I WISH I HAD READ ABOUT THESE ISSUE BEFORE BUYING MY CAR 30 DAYS AGO. I THOUGHT I HAD DONE MY HOMEWORK AND READ SEVERAL WEBSITES BEFORE BUYING THE CAR, BUT I WILL READ RECALL REPORTS BEFORE BUYING A CAR FROM NOW ON.

Dec 23, 2016

STEERING

3 complaints

MONDAY 2, 2020 AND ON THE FRIDAY BEFORE AND 2 OTHER TIMES ,THE STEERING WHEEL ICON WOULD SHOW ON DASH. AND ON AT LEAST TWICE WHILE DRIVEING STEERING WOULD LOCK UP SO BAD ,IT REQUIRED YOUR WHOLE BODY WEIGHT TO TURN A SMALL AMOUNT . THOUGHT I WAS GOING TO BE KILLED! PULLED OVER AND SHUT OFF ENGINE AND RESTARTED ENGINE AND THAT PUTS SEERING BACK TO NORMAL FOR A LITTLE WHILE. TOOK TO DEALERSHIP 11/02/2020 THEY SAID NOT UNDER WARRANTY, { 56125 MILES} BY THE WAY! TOLD ME 1400.00 PLUS TAX! THEY SAID THEY NEVER SEEN THIS BAD TOLD I SHOULDN'T DRIVE IT HOME, HAD TO FIND A RIDE HOME. THE Y WILL REPLACE THE ECU WHICH IS 700.00 BY ITSELF ON 11/03/2020. IM NOT SURE TOYOTA IS WHAT THEY USED TO BE. AND WE HAVE OWNED 5 TOYOTA'S!

Nov 03, 2020

2016 TOYOTA HIGHLANDER 30,000 MILES EPS FAILURE STEP ON THE BREAK IN THE MORNING EPS FAILURE WITH THE FLASHING LIGHT SHUT IT OFF STEP ON THE BREAK AGAIN START IT AND SOMETIMES IT'S BACK TO NORMAL READ ABOUT THE 2015 HAVING THIS PROBLEM TRULY THING THIS TRUCK WAS BUILT TOWARDS 2015 MORE THAN INTO 2016 THINK IT SHOULD BE LOOKED INTO I KNOW THEY HAD PROBLEMS IN 2015 WITH IT FOR A 2016 WITH 30,000 MILES YOU SHOULD HAVE NO PROBLEMS. TRULY WOULD LIKE TO RESPOND IN SOME SORT INVESTIGATION TO SEE IF IT WAS BUILT TOWARDS THE TAIL END OF 2015. STATIONARY ALWAYS HAPPENED STARTING IT UP HAPPENED TWICE IN DECEMBER2019 DIDN'T THINK ANYTHING OF IT STARTED HAPPENING FREQUENTLY SEPTEMBER 2020

Oct 25, 2020

I WAS JUST PROCEEDING FROM A STOP AT A 4 WAY INTERSECTION GO VERY SLOWLY WHEN I RECEIVED A WARNING ON MY DASHBOARD SAYING "EPS FAILURE, STEERING WHEEL HARDER TO TURN". I WAS THEN PHYSICALLY UNABLE TO TURN THE STEERING WHEEL, ALMOST AS IF THE POWER STEERING WAS DISABLED. THIS WAS AT AN EXTREMELY BUSY INTERSECTION AND I ALMOST HIT A TELEPHONE POLE. EVEN WHEN TRYING TO BACK UP AND TURN, MY VEHICLE WAS UNABLE TO STEER OTHER THAN GOING STRAIGHT FORWARD AND BACK. AFTER TURNING THE VEHICLE OFF AND RESTARTING IT, THE ERROR WENT AWAY AND MY STEERING RESUMED AS NORMAL, BUT I SMELLED A BURNING SMELL. THIS WAS A VERY SCARY INCIDENT AND I COULD HAVE BEEN SERIOUSLY INJURED IF I HAD HIT THE TELEPHONE POLE, IF I HAD BEEN GOING FASTER, OR SOMEONE IN THE INTERSECTION COULD HAVE HIT ME. THERE WAS A RECALL FOR THIS EXACT ISSUE IN THE 2015 MODEL AND IT SHOULD PROBABLY BE EXPANDED AS THIS ISSUE SEEMS TO EXIST WITH THE 2016 MODEL AS WELL.

Nov 01, 2018

SEATS

3 complaints

2ND ROW PASSENGER SEAT, 60 PORTION SQUEAK ON BUMPY ROADS, ISSUE COMING FROM FOLDING CABLES MECHANISM, DEALERSHIP CAN'T REPLACE THE SEAT DUE TO HIGH COST AND ALSO CAN'T FIGURE OUT A SOLUTION TO THE ISSUE, VERY ANNOYING NOISE FOR AN EXPENSIVE CAR MODEL XLE

May 28, 2019

WHEN SEATED ON FRONT PASSENGER RIGHT SIDE THE SEAT DOES RETURN TO NORMAL SHAPE. CONTACTED TOYOTA THEY REFUSED TO ADDRESS THE PROBLEM

Jun 22, 2016

WE SPECIAL ORDERED THE 2016 TOYOTA HIGHLANDER LIMITED PLATINUM MODEL. WE PURCHASED THE VEHICLE IN A TOWN APPROX 180 MILES AWAY. I WAS THE DRIVER BACK HOME. I AM 6' 1" AND WIFE IS 5' 3". WE ORDERED THE ADJUSTABLE MEMORY SEATS WHICH ARE GOOD. THE SAFETY PROBLEM WE HAVE EXPERIENCED IS THE HEADRESTS. FOR SHORTER PEOPLE THEY ARE TILTED FORWARD IN A AWKWARD POSITION. OTHER THAN AND UP AND DOWN POSITION THERE IS NO WAY TO PROPERLY ADJUST THEM. MY WIFE HAS COMPLAINED THAT SHE CANNOT BE SAFELY POSITIONED OR COMFORTABLE DRIVING WITH THE HEADREST IN THE TILTED DOWN AND FORWARD POSITION. ADJUSTING THE SEATS DOES NOT RESOLVE THE PROBLEM EITHER. THIS JUST MAKES THE VIEWING MORE DIFFICULT CREATING BLIND SPOTS. WE PAID OVER $52,000 FOR THIS EQUIPMENT VEHICLE AND EXPECTED COMFORT AND PAID FOR THE EXTRA SAFETY FEATURES. HOWEVER MY WIFE IS THE PRIMARY DRIVER (90%) OF THE TIME. HER SAFETY AS WELL AS OTHERS SHE MAY NOT BE ABLE TO SEE IS MOST IMPORTANT. I IMMEDIATELY CONTACTED THE DEALER AND EXPRESSED THE DETAILS AND SAFETY CONCERNS AS WELL AS REQUESTING A WORKABLE SOLUTION. THE SERVICE DEPARTMENT SAID THERE WAS NOTHING THEY COULD DO. THE SALES CONSULTANT WE PURCHASED THE VEHICLE FFROM SAID HE WAS AWARE OF THESE HEADREST COMPLAINTS. HE RECOMMENDED DOING WHAT OTHER DRIVERS HAVE HE TOLD US TO REVERSE THE HEADRESTS? I REMOVED AND REVERSED THEM. THIS DID NOT ACCOMPLISH A SAFE RESOLUTION. INSTEAD THE HEADRESTS SIT BACK MUCH FARTHER ENOUGH THAT WHEN THERE WOULD BE A COLLISION THE DRIVER OR FRONT PASSENGER COULD SUSTAIN SEVERE NECK INJURIES OR WORSE POSSIBLE PARALYSIS OR DEATH. I CAN JUST PLACE MY HEAD BACK ENOUGH TO TOUCH THE HEADRESTS BUT I AM THEN LOOKING UP TO THE ROOF. I IMMEDIATELY BEGAN A SAFETY COMPLAINT AND CASE WITH TOYOTA, I WAS TOLD THEY WOULD CONTACT ME IN 7 DAYS. IT'S 23 DAYS LATER. I RESEARCHED THE COMPLIANT AND FOUND THERE ARE MANY OTHER DISSATISFIED OWNERS ! UNACCEPTABLE!

Feb 05, 2016

VISIBILITY

2 complaints

The contact owns a 2016 Toyota Highlander. The contact stated that while driving approximately 20 MPH, the front right passenger's side view mirror suddenly fractured. The vehicle had not been taken to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 64,000,

Jan 10, 2024

TL* THE CONTACT OWNS A 2016 TOYOTA HIGHLANDER. WHILE DRIVING 60 MPH, THE CONTACT HEARD AN ABNORMAL EXPLOSION SOUND. ONCE THE CONTACT EXITED THE HIGHWAY AND PULLED OVER, SHE OBSERVED THAT THE SUN ROOF HAD FRACTURED. THE MANUFACTURER WAS CONTACTED AND CONFIRMED THAT THEY WERE AWARE OF THE FAILURE, BUT THERE WAS NO RECALL IN PLACE. THE CONTACT WAS ADVISED TO SCHEDULE AN APPOINTMENT AND THAT THE SUN ROOF WOULD BE REPLACED FREE OF CHARGE. THE VEHICLE WAS TAKEN TO A LOCAL DEALER (LIA TOYOTA OF WILBRAHAM, 2145 BOSTON RD, WILBRAHAM, MA, 01095) WHERE THE SUN ROOF WAS REPLACED FOR FREE. THE FAILURE MILEAGE WAS APPROXIMATELY 12,000.

Oct 19, 2017

SUSPENSION

2 complaints

Had cv boot and control arm work at 30k miles caught it in time in 2021 and dealer fixed it. 2 years later same issue if i had bot taken it to dealer and just did oil changes myself cv boot and control arm would break during operation. Seems like they have serious issues with cv boots and control arms at low miles. I only have 50k miles to have a second replacement.

Oct 30, 2023

TOWING CAPABILITIES ARE NOT CONGRUENT WITH THE SPECIFICATION PER MANUAL... REAR SUSPENSION IS VERY WEAK AND CANNOT HANDLE THE WEIGHT OF THE CABIN CARGO AND THE WEIGHT OF TRAILING UP TO 5,000 LBS SAFELY... MULTIPLE PICTURES (1 ATTACHED) TAKEN BUT DID NOT DRIVE ON THE ROAD FOR SAFETY REASONS FOR IT PASSENGERS

Sep 15, 2016

AIR BAGS,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

2 complaints

I have had problems with the brakes since I bought the vehicle new in 2016. I have the brakes checked every year and when I had problems but they never found the problem why the brakes do not work. The worse accident was on November 19, 2022 when my wife was using the car. She was in the car alone. She went to brake and the brakes did not engage, she slammed on the brakes 4 times and the car did not even slow down and she rear-ended the car in front of her. The air bags did not engage and she was injured. The brakes do not always work, I have gone through stop signs and red lights but the dealership says there is no problem.

Aug 23, 2023

Crash: 1

Injuries: 1

brakes did not work in January 13, 2023 when backing out of driveway. Have had numerous dealership look at it multiple times in last 4 years.

Jun 13, 2023

FUEL/PROPULSION SYSTEM

2 complaints

NOTED FUEL ECONOMY CONTINUES TO DROP AND NOWHERE NEAR ADVERTISED MILEAGE. LAST TRIP IN VEHICLE NOTED 20 MPG ON ADVERTISED 27MPG. AROUND TOWN MILEAGE DROPPING BELOW 19 MPG.

Aug 18, 2019

JULY 3, 2016: WE BOUGHT THE CAR. JULY 23 5PM I FILLED UP WITH GAS AT THE CHEVRON. DROVE TO WEST LA FOR 15 MILES ON THE 10 FWY WITH MY FAMILY IN THE CAR, NO PROBLEM TO VISIT MY MOM. 8:30PM WE LEFT HER HOUSE TO GO HOME. WE DROVE ON THE STREET FOR TWO MINUTES AND WE CAME TO A STOP LIGHT I BRAKED TO A COMPLETE STOP, AND THE CAR DIED. THE DASH BOARD SCREEN SAID PUT YOUR CAR IN PARK AND START THE CAR. IT WAS DARK AND MANY CARS WERE BEHIND ME, WAITING FOR ME TO START MY CAR. WE WERE AFRAID THE CAR BEHIND US WOULD HIT US. MY DAUGHTERS WERE SITTING IN THE BACK SEAT, AND MY WIFE IN THE FRONT PASSENGER SEAT. I PUT IT IN PARK, TRIED TO START. BUT IT DID NOT, SO I PUMPED THE ACCELERATOR, THEN IT STARTED. I DROVE ONTO THE FREEWAY ON RAMP, GOT ON THE 10 FWY HEADING EAST. TRAFFIC WAS GOOD AT FIRST, EVERYONE WAS GOING 60 MPH. THEN SUDDENTLY, THE THE FREEWAY TRAFFIC WAS BUMPER TO BUMPER AND I HAD TO BRAKE TO SLOW DOWN QUICKLY. WHEN I DID, THE CAR DIED ON ME AGAIN. THE DASHBOARD SCREEN SAID TO PUT THE CAR IN PARK AND START MY ENGINE. NOW, WE ALL BEGAN TO PANIC BECAUSE THE CARS BEHIND US WERE GOING FAST, AND THEY MIGHT SMASH INTO US. WE WERE AFRAID WE WOULD DIE OR BE BADLY INJURED BY THE COLLISION COMING. LUCKILY THE CAR BEHIND ME STOPPED WITHOUT HITTING US. ONCE AGAIN, I PUT IT IN PARK, PUMPED MY ACCELERATOR, AND THE CAR STARTED. AT THIS POINT, I DECIDED, NO MATTER HOW SLOW THE FREEWAY TRAFFIC IS, I WILL L NOT BRAKE, BECAUSE IF I DO, THE CAR WILL STALL, AND WE CAN GET HIT BY THE CAR BEHIND US. SO I DROVE VERY SLOWY UNTIL WE GOT OFF THE FREEWAY, AND ARRIVED HOME. AUGUST 2, 2016: 6:30AM I FILLED UP THE TANK AT THE SHELL GAS STATION NEAR MY HOUSE, BEING CAREFUL NOT TO OVERFILL IT. THEN I TRIED TO DRIVE TO WORK BUT THE EXACT SAME THING HAPPENED.

Aug 06, 2016

TIRES,WHEELS

2 complaints

2016 TOYOTA HIGHLANDER WITH OEM TOYO 245/55R19 OPEN COUNTRY M&S 103T TIRES AT ABOUT 70 MPH ON I95 SOUTH BOARD NEAR BRUNSWICK GA (EXIT 38?) , A LOUD BANG WAS HEARD AND THEN THE BUMPING MADE IT OBVIOUS A TIRE HAD FAILED SO THE VEHICLE WAS STOPPED WELL OF THE ROAD NEAR AN EXIT. THE LOCAL STATE HIGHWAY ASSISTANCE TRUCK (CHAMP) STOPPED AFTER ABOUT 20 MINUTES AND THE TOYOTA RESPONSE SERVICE TRUCK SHOWED UP ABOUT 20 MINUTES LATER - THE TIRE WAS CHANGED AND WE PROCEEDED ON OUR WAY - MANY THANKS TO THE "ROAD RANGER" AND HIS TRUCK AND EXPERTISE! THE TIRES HAD ABOUT 28,500 MILES ON THEM - ESTIMATE ABOUT 55%OF ORIGINAL TREAD AND ARE MARKED: DOT 78HH CND 1016. THERE APPEARS TO HAVE BEEN A HOLE IN THE SIDEWALL THAT CAUSED SUDDEN LOSS OF PRESSURE.

Sep 02, 2018

WE BOUGHT TIRES AND FOUND THEM TO DEFECTIVE WITHIN A FEW DAYS IN WHICH YOU HAVE 30 DAYS TO GET REFUNDED OR PAY THE DIFFERENCE FOR ANOTHER TIRES .WE DID UPGRADE TO MICHELIN TIRES BUT NOT GET THE FULL REUND FOM THE DEFECTIVE TIRES THAT GOODYEAR WANTED TO HAVE RETURNED AND INVESTIGATED ,BUT THE MANAGER HAD THEM DESTROYED TO COVER UP THE EVIDENCE AND WE LOST $321.00 AND NOW WE WILL HAVE SAMS ALSO INVESTIGATED BY THE NATIONAL HIGHWAY SAFETY FOR SELLING DEFECTIVE TIRES FROM GOOD YEAR AND COVERING IT UP.WE DEFINETLY WILL NOT LET THIS ISSUE GO BECAUSE WE FEEL THESE TIRES WERE A SAFETY ISSUE THAT SAMS AND GOOD YEAR SHOULD OF ACKNOLEGED

Mar 19, 2018

AIR BAGS,UNKNOWN OR OTHER

1 complaint

I was traveling on an interstate going home from work. My speed was approximately 65mph. I noticed traffic slowing up ahead. I began to drop my speed (cost down), as I was approaching the traffic the car in front of me was applying their brakes; I had already began to apply mine. I was applying more pressure to my brakes to slow down more as the person in front of me began to slow more quickly. The person in front of me then had to slam their brakes on and I was not able to stop in time to avoid collision with the car in front of me. That driver did not come in contact with any other vehicle. The impact was at approximately 50mph. I was then very quickly hit from behind by the car behind me. The vehicle behind me hit of center and more on the right back corner of my car. My vehicle sustained significant front-end damage; the hood was folded, the grill was gone, the radiator was pushed back. As I looked up after the impact and saw my hood folded I then noticed that my air bag had not gone off. How could the air bag have not gone off in an impact such as that. My safety was compromised by the possibility of hitting the steering wheel or worse such as impacting the windshield if the crash had been worse. I do not remember if my vehicle had side curtain air bags as well. NO air bags deployed. Law enforcement was called by the driver of the car I rear ended as we agreed that she would. The driver of the vehicle that hit me I believe also called 911. Highway Patrol responded along with state incident response vehicles to protect the scene. I have filed a claim with my insurance, and the vehicle was looked at and deemed a total loss. It is not available for inspection and was taken to a salvage yard per the insurance company. I did not notice any lights on on the dash after. I also did not encounter any issues before this. I had the vehicle just over a year.

Oct 27, 2025

Crash: 1

Injuries: 1

FORWARD COLLISION AVOIDANCE

1 complaint

On multiple (3-5), but not all, occasions at the same location my pre collision warning and automatic breaking appear to have been triggered as I approached an expansion plate at the edge of a bridge. The pre collision warning sounded, then the brakes were automatically applied. After a few seconds the braking stopped and my car proceeded normally. If a car had been following closely I may have been struck in the rear.

May 13, 2025

ELECTRICAL SYSTEM,LATCHES/LOCKS/LINKAGES

1 complaint

The contact owns a 2016 Toyota Highlander. The contact stated that while the vehicle was parked, the trunk power switch failed to function as intended. The contact stated that the trunk power switch was enabled to unlock, however the trunk door did not unlock. The contact stated that the trunk power switch failed to unlatch the trunk door and the trunk door was stuck. The vehicle was taken to an independent mechanic where it was diagnosed with battery failure due to a lack of voltage. The contact was informed that the battery needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The contact stated that the failure reoccurred intermittently. The manufacturer was made aware of the failure. The contact stated that a Representative provided remedy options over the phone. The contact stated that the failure reoccurred intermittently. The failure mileage was approximately 48,000.

Nov 20, 2024

ENGINE AND ENGINE COOLING

1 complaint

The contact owns a 2016 Toyota Highlander. The contact stated while driving 55 MPH on the highway, the contact pulled over and heard water dripping. There were no warning lights illuminated. The contact had the vehicle towed to the residence and then to the dealer where it was diagnosed as the water pump needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 90,000. The contact stated that the failure speed was actually 0 mph and the mileage was 90,723. The manufacturer was also notified of the failure.

Jun 01, 2022

ELECTRICAL SYSTEM,UNKNOWN OR OTHER

1 complaint

THE IPHONE 11 IS NOT COMPATIBLE WHICH CAUSES YOU NOT TO BE ABLE TO DRIVE HANDS FREE. EVERY TIME I TURN ON MY CAR AND CONTEXT MY PHONE MY CAR AUDIO DISCONNECTS. I CONFIRMED ON THE TOYOTA WEBSITE THAT THE IPHONE 11 IS NOT COMPATIBLE WITH TOYOTA CARS WHICH MAKES IT IMPOSSIBLE TO DRIVE HANDS FREE. *TR

May 09, 2020

ELECTRICAL SYSTEM,EXTERIOR LIGHTING

1 complaint

INTERIOR LIGHTS ON AND OFF; WARNINGS E.G .HOOD OPEN WHEN NOT; DID NOT (LIGHT) ALERT CARS ALONG SIDE OR PASSING; MODULE CRACKED BY TAPPING TO DELETE PHONE #S PUT INTO SYSTEM BY TOYOTA TECH, NAVIGATION STARTED ON ITS OWN AND IT WAS INCORRECT!; MAPS INCORRECT TO LOCATION; MAP SHOWING NORTH AS SOUTH AND EAST AS WEST ALL WHEN CAR IN MOTION

Jan 24, 2020

AIR BAGS,SEAT BELTS,SEATS

1 complaint

DOES NOT HAVE ANY SIDE AIR BAG MOUNTED PASSENGER DRIVER SEAT AIR BAG OF THE FRONT PASSENGER DRIVER ALL THE ROW FILTER IN THE GUIDE DOES NOT HAVE AIR BAG AND THE SEAT BELTS DO NOT WORK.

Jul 05, 2019

UNKNOWN OR OTHER,VISIBILITY/WIPER

1 complaint

THE WINDSHIELD CRACKED BY THE DEFROSTER. FROM THE CENTER OF THE WINDSHIELD. THE BREAK IS ON THE INSIDE GOING DOWN TO THE DEFROSTER AND THEN ACROSS THE DRIVERS SIDE OF THE WINDSHIELD. THE VEHICLE WAS PARKED, THE WHEN IT WAS STARTED, THE DEFROSTER WAS PUT ON HIGH FAN. AFTER A FEW MINUTES THE CRACK APPEARED IN THE CENTER GOING DOWN TOWARDS THE DEFROSTER AND THEN ACROSS THE LOWER PORTION OF THE WINDSHIELD ON THE DRIVERS SIDE.

Mar 18, 2019

EXTERIOR LIGHTING,UNKNOWN OR OTHER,SERVICE BRAKES

1 complaint

BRAKES HAVE A SLIGHT VIBRATION WHEN TRAVELING AT HIGH SPEEDS IN THE CITY AND SOMEONE IS STOPPED ON THE FREEWAY. MY LIGHTS HAVE DIMMED DRAMATICALLY SINCE I FIRST PURCHASED NEW. THE PASSENGER SIDE DAYTIME RUNNING LIGHT IS FULL OF MOISTURE. MOST IMPORTANTLY, THE TEMPERATURE SENSOR AND/OR AC FAN/MOTOR IS HALFWAY FUNCTIONING AT 38K! BY THIS, I MEAN THAT THE AC IN THE FRONT OF THE CAR KICKS ON AND OFF IN THE MIDDLE OF COOLING AND IT BLOWS 50% OF WHAT IT DID WHEN I BOUGHT THE CAR. CONVENIENT TOYOTA?

Nov 15, 2018

WHEELS

1 complaint

ON NOVEMBER 27 2017 THE RIGHT REAR TIRE SUFFERED A MAJOR BLOWOUT CAUSING THE VEHICLE TO GO OUT OF CONTROL. I WAS ABLE TO STABILIZE THE VEHICLE. AAA PLACED THE SPARE ON THE VEHICLE AND WE DROVE IT TO LAKELAND TOYOTA IN LAKELAND FLORIDA. THEY GAVE US A RENTAL VEHICLE AND SAID THEY WOULD REPLACE THE TIRE IN A COUPLE OF DAYS. WE WERE ON OUR WAY TO PORT CANAVERAL TO GO ON A CRUISE. ON FRIDAY WE RETURNED TO THE DEALERSHIP AND WAS ADVISED THAT THEY WOULD NOT HONOR THE WARRANTY ON THE TIRE AND CHARGED US $327.09 FOR A NEW TIRE. I REQUESTED. THE OLD TIRE SO I COULD HAVE IT EXAMINED AND THEY SAID THEY HAD TURNED IT OVER TO WASTE DISPOSAL. I ADVISED THEM THAT VIOLATED THE SPOILATION DOCTRINE IN THIS STATE. THE VEHICLE AND TIRE HAD 6805 MILES. AT THE TIME OF THE BLOWOUT THE VEHICLE WAS IN MOTION DRIVING THE SPEED LIMIT OF 70MPH ON INTERSTATE 4 ON THE WAY TO PORT CANAVERAL. I HAVE THE RECORDS OF LAKELAND TOYOTA FOR YOUR REVIEW...THE TIRE WAS A BRIDGESTONE DUELER HL 422 P245/55R19. I TOLD THE CUSTOMER SERVICE REPRESENTATIVE THAT IT WAS WRONG FOR THEM TO NOT HONOR THE WARRANTY ESPECIALLY IN LIGHT OF PRIOR PROBLEMS WITH BRIDGESTONE/FIRESTONE TIRES..AND THEY SHOULD REPORT THE MATTER TO YOUR AGENCY

Dec 02, 2017

AIR BAGS,SERVICE BRAKES

1 complaint

TL* THE CONTACT OWNS A 2016 TOYOTA HIGHLANDER. WHILE DRIVING APPROXIMATELY 20 MPH, THE BRAKES MALFUNCTIONED AND THE CONTACT'S VEHICLE REAR ENDED ANOTHER VEHICLE. THE CONTACT STATED THAT THE VEHICLE FAILED TO STOP WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT'S VEHICLE SUSTAINED SIGNIFICANT FRONT END DAMAGE, BUT THE AIR BAGS DID NOT DEPLOY. THE FRONT PASSENGER SUSTAINED CHEST INJURIES THAT DID NOT REQUIRE MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED FROM THE SCENE. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE LOCAL DEALER (KENNY KENT TOYOTA IN EVANSVILLE, IN) WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 6,600.

Sep 28, 2017

Crash: 1

Injuries: 1

STRUCTURE,VEHICLE SPEED CONTROL,SERVICE BRAKES

1 complaint

I WAS IN A PARKING LOT TRYING TO PARK MY CAR I PUT MY FOOT ON THE BREAK TO STOP THE CAR AND PUT INTO REVERSE AND THE CAR ACCELERATED INSTEAD OF STOPPING. THE HARDER I PUSHED THE BREAKS THE FASTER IT ACCELERATED AND HIT THE CAR PARKED IN FRONT OF ME.

Jul 07, 2017

Crash: 1

VEHICLE SPEED CONTROL,UNKNOWN OR OTHER

1 complaint

WHEN THE CRUISE CONTROL IS ENGAGED AND THE VEHICLE IS ON A DECLINE THE CRUISE CONTROL DOES NOT MAINTAIN THE SET SPEED. I NOTICED THIS SEVERAL TIMES WHILE ON THE INTERSTATE TRAVELING BETWEEN 65-75 MPH. EACH TIME THERE WAS A CAR AHEAD OF ME AND I NARROWLY AVOIDED WHAT COULD HAVE BEEN TRAGIC ACCIDENTS. THE FIRST TIME IT HAPPENED I THOUGHT IT WAS A FLUKE SO I CONTINUED TO USE THE CRUISE CONTROL AS I WOULD NORMALLY DO. AFTER IT HAPPENED AGAIN I DECIDED NOT TO USE THE CRUISE CONTROL AT ALL WHICH WAS VERY FRUSTRATING CONSIDERING THE VEHICLE WAS LESS THAN 2 WEEKS OLD AND I PURCHASED IT JUST FOR LONG FAMILY TRIPS. THERE IS ALSO A WIND WHISTLING NOISE COMING FROM THE PASSENGER SIDE OF THE VEHICLE. I TOOK IT TO DEALERSHIP FOR THE NOISE ISSUE AND I WAITED THERE FOR 5 HOURS ONLY FOR THEM TO TELL ME THAT IT'S A KNOWN ISSUE AND THERE IS NO FIX FOR IT. THIS HAS TURNED OUT THE BE THE WORST CAR EXPERIENCE I'VE EVER HAD.

Mar 11, 2017

VEHICLE SPEED CONTROL,SERVICE BRAKES

1 complaint

MY WIFE WAS DRIVING WITH OUR TWO DAUGHTERS (AGES 12 AND 14). IT HAD JUST STARTED TO SNOW AND MY WIFE SAID THE ROAD WAS SLIPPERY SHE PUT THE CAR INTO LOW GEAR AND TRAVELED SLOWLY. SHE WAS RIGHT AROUND THE CORNER FROM OUR HOUSE WHEN SHE COULD NO LONGER CONTROL THE VEHICLE. SHE HIT A TREE, A FENCE, AND THEN TWO MORE TREES, TRAVELING MORE THAN 600 FEET. EVEN THOUGH SHE WAS TRAVELING DOWNHILL SHE SAID THE BRAKES DID NOT ENGAGE THE ABS AND THEN TOWARD THE END OF THE CRASH, BEFORE HITTING THE THIRD TREE THE CAR ACCELERATED ON ITS OWN. UPON HITTING THE THIRD TREE ALL AIR BAGS DEPLOYED AND FIRE, POLICE, AND AMBULANCE ARRIVED AT THE SCENE AND TOOK THEM ALL TO THE HOSPITAL. THEY HAD X-RAYS AND THERE WERE NO BROKEN BONES. OUR YOUNGER DAUGHTER WAS VERY TRAUMATIZED AND EVERYONE HAD BRUISES AND SMALL CUTS FROM SEAT BELTS BUT ALL WERE GENERALLY OKAY. THE STRANGE THING ABOUT THIS ACCIDENT IS HOW FAR THE CAR TRAVELED DESPITE MY WIFE'S EFFORTS TO STOP THE CAR. SHE HAD ALREADY PLACED THE CAR IN LOW GEAR YET THE BRAKES DID NOT WORK AND SHE SAYS THE CAR INCREASED SPEED (NOT JUST DUE TO THE SLOPE DOWNWARD). OUR FAMILY HAS LIVED IN THIS AREA FOR YEARS AND DRIVEN THROUGH COUNTLESS SNOW STORMS. THIS WAS NOT EVEN A STORM BUT JUST SOME LIGHT SNOW. IT WAS SLIPPERY ACCORDING TO MY WIFE BUT THE FACT THAT SHE COULD NOT STOP THE VEHICLE OVER SUCH A LONG DISTANCE DOES NOT MAKE SENSE AND SHE FEELS THAT THE CAR FAILED IN MULTIPLE WAYS. PLEASE SEE ATTACHED CRASH REPORT. THANK YOU. UPDATED 03/07/17*LJ *CN

Feb 06, 2017

Crash: 1

Injuries: 3

FUEL SYSTEM, GASOLINE,VEHICLE SPEED CONTROL,ENGINE

1 complaint

OCCASIONALLY, AT A STOP SIGN/INTERSECTION OR ENTERING A HIGHWAY IF I HAVE COME TO A FULL STOP BEFORE PROCEEDING THE CAR WILL STALL. I PRESSED ON THE ACCELERATOR AND NOTHING HAPPENS. MY WIFE AND I HAVE FOUND OURSELVES IN THIS PREDICAMENT SEVERAL TIMES NOW AND IT IS ONLY GETTING WORSE. THIS SCENARIO IS VERY DANGEROUS FOR SEVERAL REASONS, BUT THE MOST IMPORTANT ONE IS THAT MY FAMILY HAS BEEN INSIDE THE CAR WHEN THIS HAS HAPPENED. WE HAVE HAD SEVERAL SCARES NOW, BECAUSE THE CAR STALLED ON US AS WE WERE ENTERING THE HIGHWAY. I HAVE SPOKEN TO THE DEALER ABOUT THIS OVER THE PHONE AND BOTH TIMES THAT THE CAR HAS BEEN SERVICED. AFTER THEY TEST DROVE THE VEHICLE, I WAS TOLD THAT THIS WAS NORMAL BEHAVIOR DUE TO A DELAY BETWEEN THE COMPUTER AND THE ACCELERATOR THROTTLE. ADDITIONALLY, I WAS ALSO TOLD THAT TOYOTA IS AWARE OF THIS, BUT HAS NOT ADDRESSED THE PROBLEM. THIS IS EXTREMELY UPSETTING BECAUSE MY FAMILY IS NOW AT RISK DUE TO A COMPUTER MALFUNCTION. I URGE THE NHTSA TO PLEASE LOOK INTO THIS MATTER AS MORE AND MORE PEOPLE BASED ON INTERNET SEARCHES ARE DEALING WITH THIS SAME ISSUE. I OWN A 2005 HIGHLANDER WITH 105000 MILES AND THIS HAS NEVER HAPPENED. YOU WOULD THINK THAT A 2016 MODEL WITH ALL OF ITS SAFETY FEATURES AND ENHANCEMENTS WOULD BE A PLEASANT DRIVING EXPERIENCE? BUT, NOW THAT I OWNED THE CAR FOR ALMOST 8 MONTHS I AM SECOND GUESSING MYSELF WHETHER THIS WAS THE RIGHT PURCHASE. ONCE, AGAIN I URGE THE NHTSA TO LOOK INTO THIS AND TO ANYONE ELSE OUT THERE THAT IS EXPERIENCING THE SAME ISSUE, PLEASE SPEAK UP SO THAT BOTH TOYOTA AND THE NHTSA ADDRESS THIS PROBLEM AS SOON AS POSSIBLE. *TR

Feb 02, 2017

STEERING,FUEL/PROPULSION SYSTEM

1 complaint

BRAND NEW CAR IN THE SHOP TWICE DURING FIRST WEEK. FOLLOWING REFUELING (NOT TOPPED OFF - STOPPED AT FIRST CLICK) THE CAR STARTS STALLING AT RED LIGHTS OR AT LOW SPEEDS. HAS DONE THIS A DOZEN TIMES. ON THE HIGHWAY CAR STUTTERS, CHECK ENGINE LIGHT COMES ON AND TRACTION CONTROL BECOMES DISABLED. THE DEALERSHIP SAYS THIS IS DUE TO OVERFILLING THE GAS TANK AND CHANGED THE CARBON CARTRIDGE FOR THE EVAC THIS IS DEFINITELY NOT THE CASE. A SECOND REFILL AFTER THE REPAIR CONFIRMED THAT THE PROBLEM EXISTS EVEN WHEN FILLING UP VERY CAREFULLY. IF GASOLINE IS FILLING UP THIS COMPONENT THEN THERE IS SOMETHING SERIOUSLY WRONG WITH THIS VEHICLE AND ITS DANGEROUS TO DRIVE. AGAIN THIS CAR IS ONLY 9 DAYS OLD AND IN THE SHOP TWICE FOR THE SAME REASON. LOSING POWER AT A BUSY INTERSECTION IS DANGEROUS AS THIS HAS HAPPENED IN AREAS WHERE CARS ARE MOVING QUITE FAST. I WAS ALMOST REAR ENDED WHEN MY CAR STALLED.

Apr 18, 2016

2016 TOYOTA Highlander Problems & Complaints

Complaints by Component

Frequently Asked Questions

How many problems does the 2016 TOYOTA Highlander have?

What are the most common problems with 2016 TOYOTA Highlander?

Where does this 2016 TOYOTA Highlander problem data come from?

Other Years - TOYOTA Highlander

Other TOYOTA Models

Similar Brands