How many problems does the 2012 TOYOTA Tacoma have?

The 2012 TOYOTA Tacoma currently has 291 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2012 TOYOTA Tacoma?

The most common problems reported for the 2012 TOYOTA Tacoma are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2012 TOYOTA Tacoma problem data come from?

All problem and complaint data for the 2012 TOYOTA Tacoma comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.

2012 TOYOTA Tacoma Problems

ENGINE

80 complaints

MY 2012 TACOMA WARNING LIGHT 1) ENGINE AND 2 TRAC OFF WARNING LIGHT CAME ON AND LOST POWER GOING 65 MPH ON FREEWAY AND WOULD NOT GO OVER 25 MPH (DANGEROUS!). OBD-II SCANNER DISPLAYED ERROR CODE CHECK P2442 INDICATING FAULTY AIR INJECTION PUMPS AND/OR AIR SWITCHING VALVES. *TR

May 11, 2020

ON MY 2012 TACOMA THE CODE P2440 AND P2442 WHICH REPRESENT A STUCK OPEN VALVE IN THE SECONDARY AIR INJECTION SYSTEM. UPON MY RESEARCH INTO THIS ISSUE ON FORUMS I HAVE LEARNED THIS IS A COMMON PROBLEM WITH THE TOYOTA SYSTEMS PARTICULARLY THE 2012 TACOMA. THE COST OF THE PART IS ABOUT 400 TO 500 DOLLARS FOR THE VALVES AND ANOTHER 500 DOLLARS FOR THE SECONDARY AIR INJECTION PUMP. THE FAILURE WILL PLACE THE VEHICLE INTO A LIMP MODE AND HAS TO BE FIXED IN ORDER TO THE TRUCK TO KEEP ON GOOD WORKING CONDITION. IT SEEMS LIKE THIS ERROR HAS AFFECTED MANY TACOMA OWNERS. *TR

Apr 11, 2020

TWO DASHBOARD LIGHTS ILLUMINATED AT THE SAME TIME: THE CHECK ENGINE LIGHT AND THE TRAC OFF LIGHT. AT FIRST I REALLY DIDN'T NOTICE MUCH OF A DIFFERENCE BUT AFTER 2 DAYS I EXPERIENCED SIGNIFICANT POWER LOSS. I WOULD PULL OUT INTO TRAFFIC OK UNTIL ABOUT 20MPH THEN HAVE NO POWER. IT CRAWLED WHILE TRYING TO GET UP TO SPEED. I READ ON THE INTERNET THAT IF YOU DISCONNECT THE BATTERY AND OPEN THE GAS CAP THE LIGHTS WOULD GO OUT AND THE PROBLEM WOULD GO AWAY. I DID THIS AND IT WORKED; OR SO I THOUGHT. I THEN LEFT FOR AN HOUR TRIP (I KNOW DUMB) AND WITHIN 15 MINS THE LIGHTS CAME BACK ON AND I COULDN'T GET THE TRUCK OVER 60MPH ON A MAJOR HIGHWAY. I ACTUALLY STOPPED AT A REST STOP AND DISCONNECTED THE BATTERY AND REMOVED THE GAS CAP. AGAIN THIS SHUT OFF THE LIGHTS BUT ONLY FOR ABOUT 5 MINS. THEN THE POWER LOSS WAS BACK. TOOK TO MY LOCAL MECHANIC WHO I TRUST AND HE SAID IT WAS A KNOWN PROBLEM THAT WAS SOMETHING CALLED A TECHNICAL SERVICE BULLETIN BUT NOT YET A RECALL. APPARENTLY THE TUNDRA AND SEQUOIA ARE RECALLED FOR THIS PROBLEM BUT NOT THE TACOMA. I DON'T GET IT. I WAS TOLD TO KEEP MY RECEIPTS ($1,870.68) RIGHT AFTER CHRISTMAS THANK YOU, AND HOPEFULLY ONE DAY GET REIMBURSED IF IT BECOMES A RECALL. I CAN ONLY HOPE THIS IS A NO INTEREST INVESTMENT INTO MY FUTURE. *TR

Jan 27, 2020

FAILURE OF THE SECONDARY AIR INJECTION SYSTEM P2440 AND P2442, WHILE THE VEHICLE WAS MOVING ONTO A CITY STREET FROM A PARKING LOT. WHEN ACCELERATING IMMEDIATELY THERE WAS A DECREASE IN POWER AND THE CHECK ENGINE LIGHT ALONG WITH THE "TRAC OFF" LIGHT ILLUMINATING SIMULTANEOUSLY. THE VEHICLE HAS A NOW MAXIMUM SPEED OF AROUND 55 MPH AND EXTREMELY SLOW TO ACCELERATE BEING ALMOST DANGEROUS ON BUSIER ROADS. AFTER BEING CHECK OUT BY A THE DEALER IT WAS FOUND TO BE THE SECONDARY AIR INJECTION SYSTEM WHICH IS COVERED BY AN EXTENDED WARRANTY BUT PARTS ARE ON BACK-ORDER.

Dec 31, 2019

WHILE ON A ROAD TRIP I HAD MY CHECK ENGINE LIGHT COME ON WHILE ON THE HIGHWAY DUE TO DEFECTIVE SECONDARY INJECTION VALVES BEING STUCK CLOSED/OPEN. THE CODES I HAD FOR THIS ISSUE IS P2440 AND P2442. IN MY CASE THIS ISSUE MADE MY TRUCK GO INTO LIMP MODE WHICH IS OFTEN A LOSS OF POWER IN THE ENGINE AND SOMETIMES A RESTRICTION IN ONE'S ABILITY TO SHIFT THE TRUCK. LUCKILY THE HIGHWAY WAS NOT BUSY AT THE TIME THIS HAPPENED, BUT IF IT WERE I WOULD BELIEVE THAT IT WOULD BE A VERY UNSAFE THING TO HAPPEN GOING 70 MPH. THE PARTS DO HAVE AN EXTENDED WARRANTY UNTIL 2022 IF I REMEMBER RIGHT, BUT IT SEEMS LIKE TOYOTA IS NOT INTERESTED IN RECALLING THESE PARTS EVEN AFTER THEY HAVE KNOWN FOR MANY YEARS THAT THESE PARTS ARE DEFECTIVE. I HAVE DONE QUITE A BIT OF RESEARCH AND FOUND ISSUES WITH THESE PARTS GOING BACK TO 2013.

May 18, 2019

+ 75 more complaints for this component

FUEL/PROPULSION SYSTEM

28 complaints

The check engine light on the dashboard of my 2012 Tacoma turned on and will no longer accelerate appropriately and especially while driving uphill, posing a danger to myself and other drivers. I was on a two-lane highway with a cliffside drop on one side and a wall of steep rock on the other and absolutely no where to go as there was only one lane going in each direction and my truck would not accelerate over 20mph in an area where you’re expected to keep a pace above 40mph and as such ended up with a long row of impatient and increasingly frustrated drivers behind me, only more incited by my having to turn on my hazard lights as a result of a crawling speed I was forced to deal with and with nowhere to pull over and get out of the way. How can I possibly rely on this vehicle to be safe for me or anyone else, especially on a fast-moving highway in this condition? I have taken the vehicle to an auto shop and I as told the air injection system is bad and that this is a typical problem for Toyota Tacomas and the cost would be just shy of $3,000! I was recommended by a mechanic to reach out to Toyota directly because this is obviously an issue the manufacturer should readily respond to and repair. Please advise.

Sep 15, 2023

Switching valve stuck open bank 1 and 2. Truck is in limp mode. Air pump is full of water.

Jun 13, 2021

TRAC OFF AND CEL ON, TRUCK GOES INTO 'LIMP MODE' AND DECELERATES WHEN GAS ALLPIED. LOUD WHINING NOISE WHEN FIRST STARTING.

Sep 07, 2020

MY CHECK ENGINE LIGHT CAME ON AND I HAD NO ACCELERATION BEYOND 20 MPH. I TOOK IT FOR A DIAGNOSIS AT AUTO ZONE AND THEY TOLD ME IT WAS CODES ,2450 AND 2442, SECONDARY AIR VALVES STUCK OPEN. I AM STUCK IN AN UNFAMILIAR CITY AND NO MECHANICS WITH TIME TO FIX IT, TO SAY NOTHING OF ME NOT HAVING THE FUNDS TO PAY FOR THE REPAIR. THE LIGHT CAME ON WHEN I WAS TURNING A CORNER ON A HILL. I UNDERSTAND THIS HAS BECOME A VERY COMMON PROBLEM FOR TOYOTAS AND I WOULD HAVE EXPECTED A RECALL NOTICE SO THAT TOYOTA WOULD FIX THE PROBLEM! I HAVE NO WAY OF GETTING HOME AS PART OF MY DRIVE IS THRU A VERY STEEP AND TREACHEROUS CANYON.

Aug 08, 2019

ABOUT 2 WEEKS AGO MY TRUCK WAS HESITATING AND MY CHECK ENGINE/OFF TRAC LIGHT WAS ON. THE CAR WOULD NOT GO ABOVE 40MPH ON CITY STREETS OR HIGHWAY. I WENT TO A TOYOTA DEALER IN PUERTO RICO, THEY SAID THE CODES WERE P0052, P0456, P2140, P2442 SECONDARY AIR INJECTION SYSTEM IS BAD AND WOULD COST $2,458.08 FOR REPAIRS. I DON'T KNOW IF IT IS COVERED BY ANY WARRANTY. IT IS A 2012 TOYOTA TACOMA PRE-RUNNER.

Jul 28, 2019

+ 23 more complaints for this component

UNKNOWN OR OTHER

23 complaints

The frame has rusted through in several spots.

Sep 23, 2021

I was attempting to park in a parking space to return items at a department store at a mall. All of a sudden my truck accelerator on its own. The truck traveled over two cements curbs crossed a road before traveling through a chain-link fence down the front of retaining wall into a wooded area swamp. It took three tow trucks to remove the truck. Police report 21-374-AC. Truck wasn't repairable so my insurance company totalled the truck. I filed a complaint with Toyota in Case number 210602000065 but no outcome. This is the second time this truck has had accelerator issues. My first complaint was Aug 2019 with Toyota case number 1908060035. Toyota pulled the black box and came back stating they couldn't find anything.

Jul 04, 2021

Crash: 1

Injuries: 1

21012 TACOMA WITH 52,000 MILES IN NEED OF REPLACEMENT AIR SWITCHING VALVES, AIR PUMP & GASKETS. KNOWN PROBLEM WITH TOYOTA OF WHICH THEY ONLY MADE A HANDFUL OF RECALLS TO OWNERS. $1500 FOR REPAIRS THAT SHOULD BE COVERED BY TOYOTA

Apr 23, 2020

THE CODES FOR THE AIR SWITCHING VALVE.

Jun 10, 2019

THE HORN DOESN'T WORK. THE PROBLEM HAS BEEN DIAGNOSED AS "CLOCK SPRING" AND THE COST TO FIX IT IS ALMOST $500. THIS IS A LOT TO PAY FOR SOMETHING THAT SHOULD NEVER GO OUT! RELAY AND FUSE CHECKED OUT.

Jul 24, 2018

+ 18 more complaints for this component

SUSPENSION

15 complaints

My leaf spring(s) is noisy/loosened and to the best of my limited knowledge is at risk for breaking off and puncturing the fuel tank per repair shops. This issue is not covered under Safety Recall E02 (E12) by Toyota for the model year 2012 Tacoma. As a consumer, I don't understand the determination of when the recall is cut off for specific model years. I would like for NHTSA and Toyota to analyze this issue as the model year 2012 Tacoma could be at risk. I have case with Toyota Customer Resolutions that has been closed. Thanks for your attention into this matter.

Jun 02, 2025

The passenger leaf spring or right leaf spring has broken and the truck has not hauled any kind of weight, there is a previous recall on similar trucks but they end with 2011 models but looking at the 2012 model it’s build is similar and seems to have a chance of having the same effect as mine already has.

Sep 08, 2021

Is there a recall on leaf springs

Jun 19, 2021

HAVING THE SAME ISSUE AS THE 2011 TACOMA'S WITH FAULTY LEAF SPRINGS STARTED AS A SQUEAK SPRAYED WD-40 AND FLUID FILM DIDN'T HELP THEN FEW MONTHS LATER HEARD A CLUNK AND NOW DRIVER SIDE LEAF SPRING IS BROKE THIS SHOULD BE COVERED UNDER THE RECALL!!

Apr 15, 2021

FAILURE OF DRIVERS SIDE LEAF SPRING WITH LARGE SECTION(4-6IN) MISSING. GAVE NO NOTICE OF FAILURE PRIOR TO FAILING. FOUND WHEN CHANGING TIRES. DO NOT USE VEHICLE FOR TOWING BEYOND SPECS OR OFF ROADING. TOYOTA RECALLED PREVIOUSLY FOR THIS ISSUE UNDER SAFETY RECALL E02(E12) FOR 2005-2011 M.Y. STATING BROKEN LEAF SPRINGS COULD PUNCTURE FUEL TANK PROPAGATING IN A FIRE. TOYOTA DEALERSHIP WAS UNWILLING TO ASSIST IN REPAIR OR ADMIT FAULT DESPITE SAFETY RELATED ISSUE.

Sep 23, 2020

+ 10 more complaints for this component

POWER TRAIN

14 complaints

My truck started having a vibration when driving around 45-55 mph. This problem first became noticeable when it had about 115,000 miles on it. Over time the speed that the vibration became noticeable at gradually increased. By 125,000 miles on the truck, it was vibrating hard between 60 and 70 mph. The dealership determined that the problem was that the drive shaft was out of balance and that it had to be replaced. They replaced the drive shaft, but this doesn't seem like a problem that should creep up with that relatively few miles on the vehicle, and I have read that if the drive shaft actually fails, it can severely damage the vehicle and potentially cause injury.

Dec 28, 2024

Drivetrain vibration and cricket chripping noise; likly coming from propeller shaft

Nov 11, 2022

DRIVE TRAIN VIBRATION. TOYOTA HAS A WARRANTY ENHANCEMENT PROGRAM FOR THIS ISSUE THROUGH THE 2011 MODEL, BUT THIS IS A 2012 MODEL WITH SAME ISSUE. SITUATION OCCURS DURING ACCELERATION.

Jan 10, 2019

TL* THE CONTACT OWNS A 2012 TOYOTA TACOMA. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE FAILED TO ACCELERATE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO DAYTON TOYOTA (2291 US-130, DAYTON, NJ 08810, 732-329-9191), BUT THE FAILURE COULD NOT BE DUPLICATED. THE FAILURE RECURRED SEVERAL TIMES AND THE VEHICLE WAS TAKEN BACK TO THE SAME DEALER. THE TECHNICIAN DIAGNOSED THAT THE CLUTCH NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND OFFERED TO COVER THE COST OF THE PARTS WHILE THE CONTACT COVERED THE LABOR COST. THE FAILURE MILEAGE WAS 33,000.

Apr 05, 2018

I HAVE 27,000 MILES ON MY TRUCK AND THE REAR DIFFERENTIAL IS DEFECTIVE. I AM AFRAID IT WILL LOCK UP AT HIGH SPEEDS, 55 MPH + AND CAUSE AN ACCIDENT!! TOYOTA WON'T FIX IT

Jun 30, 2017

+ 9 more complaints for this component

ENGINE,FUEL/PROPULSION SYSTEM

9 complaints

RECENTLY I WAS DRIVING MY 2012 TOYOTA TACOMA ON THE HIGHWAY AT A SUSTAINED SPEED OF 70 MPH. A CHECK ENGINE LIGHT CAME ON AND MY CAR INSTANTLY DROPPED IN SPEED TO LESS THAN 40 MPH WHILE IN FAST MOVING TRAFFIC. I WAS ALMOST REAR ENDED BY A LARGE TRUCK AND WAS FORCED TO CROSS MULTIPLE LANES OF TRAFFIC TO GET TO THE BERM AND ASCERTAIN THE SITUATION. AS I COULD FIND NO ISSUES UPON INSPECTION, I PRECARIOUSLY DROVE THE VEHICLE TO A SERVICE STORE TO READ THE ERROR CODES. THE VEHICLE SHOWED P2440 P2442 ERROR CODES INDICATING SECONDARY AIR INJECTION FAILURES. APPARENTLY, THE VEHICLE WENT INTO LIMP MODE UPON THROWING THESE CODES WHICH LIMITS SPEED AND ENGINE RPM. THIS ALMOST CAUSED A HUGE ACCIDENT AND PUT ME INTO A A VERY DANGEROUS SITUATION. ADDITIONALLY UPON RESEARCHING THESE ISSUES, IT SEEMS THIS IS A WELL DOCUMENTED ISSUE CAUSED BY MANUFACTURING DEFECTS ISOLATED TO THE 2012 MODEL YEAR. APPARENTLY, THE SYSTEM IS DEFECTIVE IN MULTIPLE WAYS. FIRST, A PIECE OF FOAM IS INSIDE THE SECONDARY AIR PUMP WHICH DEGRADES AND IS SUCKED INTO THE FAN WHICH NOT ONLY CAUSES STOPPAGE AND BURNING OUT THE FAN MOTOR BUT ALSO ALLOWS FOR STINKY RESIDUE AND DEBRIS TO ENTER THE VALVES CAUSING THEM TO JAM OPEN OR CLOSED. ADDITIONALLY, THE SYSTEM ALLOWS MOISTURE TO BE SUCKED INTO THE VALVES ADDING TO CORROSION AND DEGRADATION OF THE VALVES LEADING TO THEM TO BE STUCK. THIS IS A ROUGHLY 1500.00-2000.00 REPAIR. IT IS A QUITE FREQUENT PROBLEM WITH THIS MODEL YET IS NOT COVERED UNDER RECALL OR SERVICE BULLETIN. TOYOTA HAS ACKNOWLEDGED THE ISSUE YET NOT TAKEN ANY ACTION. ADDITIONALLY, THEY HAVE HAD SIMILAR PROBLEMS WITH THE TUNDRA/SEQUOIA AND OFFERED REMEDY TO OWNERS VIA EXTENDED WARRANTY. THIS IS NOT ONLY A QUALITY CONTROL ISSUE BUT MORE IMPORTANTLY A SEVERE SAFETY ISSUE WITH THE AUTOMATIC REDUCTION TO A SLOW SPEED IN FAST HEAVY TRAFFIC.

Nov 05, 2017

ERROR CODE P2442 SECONDARY AIR INJECTION VALVE STUCK OPEN. TRUCK IMMEDIATELY GOES INTO "LIMP' MODE AND WILL NOT ACCELERATE OVER 20MPH. EXTREMELY UNSAFE TO HAVE THE VEHICLE DECELERATE ON A HIGHWAY FOR A KNOWN ISSUE THAT HAS PROMPTED WARRANTY EXTENSIONS ON TOYOTA TUNDRA'S.

Sep 27, 2017

FAILURE OF THE SECONDARY AIR INJECTION PUMP AND VALVE EMISSION SYSTEM PROMPTED ENGINE TO RUN IN A REDUCED POWER MODE, AND THIS OCCURRED ON A ON A RELATIVELY NEW VEHICLE WITH BELOW AVERAGE MILEAGE. WHILE SETTING MAY PROTECT ENGINE, THIS CREATED AN UNSAFE DRIVING ENVIRONMENT FOR VEHICLE WITHIN FAST MOVING TRAFFIC. MY COMPLIANT IS NOT RELATED TO THE REDUCED DRIVING MODE THAT MAY HAVE PROTECTED THE ENGINE, BUT RATHER THE POOR DESIGN OF THE AIR-PUMP/VALVE SYSTEM THAT PREMATURELY FAILED CAUSING THE REDUCED POWER MODE.

May 31, 2017

2012 TACOMA WITH 24K MILES. CHECK ENGINE LIGHT AND TRC LIGHT CAME ON WITH TRUCK IN LIMP MODE WHEN I STARTED IT TO GO TO WORK. CODES P0412 P2433 P2438 P2442. TOYOTA WONT COVER THIS AND ITS A DEFECT IN MANY MANY 2012 TACOMAS.

May 09, 2017

EMISSIONS AIR PUMP VALVE WENT OUT WITH 60,200 MILES ON THE TRUCK. THE TRUCK IS BONE STOCK AND HAS BEEN VERY WELL MAINTAINED. AFTER RESEARCH ITS SEEMS THAT NUMEROUS PEOPLE ARE HAVING ISSUES WITH THIS SAME EXACT PART ON THE 2012 TACOMAS. TOYOTA EXTENDED A RECALL ON THE TUNDRA'S BECAUSE OF THIS PART, BUT NOT THE TACOMAS. THE TRUCK IS CURRENTLY IN LIMP MODE AND WILL NOT GO PAST 40MPH, AND THE DEALER WANTS $1,075 TO FIX IT. THIS OCCURRED ON MY WAY TO WORK THIS MORNING WHILE GETTING ON THE FREEWAY, AND WAS QUITE SCARY TO NOT BE ABLE TO GO OVER 40MPH ON A BAY AREA FREEWAY WITH CARS HONKING AND FLYING PAST ME.

May 04, 2017

+ 4 more complaints for this component

SERVICE BRAKES

9 complaints

SHORTLY AFTER BUYING MY TACOMA NEW I NOTICED THAT MY ANTI-LOCK BRAKES WERE SENSITIVE AND WOULD LOCK UP WITHOUT WARNING AND THE STOPPING DISTANCE CAN VARY EVERY TIME I APPLY THE BRAKES. I BROUGHT THIS UP TO MY DEALER'S SERVICE DEPARTMENT DURING ROUTINE OIL CHANGES AND WAS TOLD THAT THIS IS NORMAL. THE VARIED STOPPING DISTANCE CAUSES PROBLEMS SINCE THE TRUCK COULD SUDDENLY STOP SHORTER THAN NORMAL AND CATCH TRAFFIC BEHIND ME OFF GUARD AND CAUSE AN ACCIDENT. OTHER TIMES IT FEELS LIKE THE BRAKES AREN'T WORKING EVEN THOUGH I AM PRESSING FIRMLY AND WONDERING IF I'M GOING TO STOP IN TIME TO AVOID HITTING A CAR IN FRONT OF ME. ON EMERGENCY QUICK STOPS MY BRAKES WILL LOCK UP AND WITH THE VARIED STOPPING DISTANCES I'M SURPRISED I HAVEN'T BEEN IN A POSITION WHERE THE STOPPING DISTANCE IN AN EMERGENCY WAS MORE THAN NORMAL CAUSING ME TO CRASH. I WOULD SAY THAT MY ONLY COMPLAINT SO FAR ON THIS TRUCK IS THE BRAKES AND MUCH BETTER THAN THE TRUCK THAT I TRADED IN BECAUSE OF SEVERAL PROBLEMS WITH IT'S ELECTRICAL, BRAKING (IT'S BRAKES WERE POOR BUT AT LEAST YOU COULD STOP WHEN YOU WANTED), BUILD QUALITY, AND OTHER ISSUES. THIS CLEARLY ISN'T NORMAL AND IF THE DEALER SAYS IT IS, HOW CAN SOMEONE GET IT FIXED WITHOUT TRADING IT IN. THIS IS THE ONLY ISSUE I HAVE WITH THIS TRUCK BUT IT'S BIG ENOUGH TO TRADE IT IN. I SPENT $30K FOR THIS TRUCK AND WOULD RATHER KEEP IT BUT IT HAS GOTTEN TO THE POINT THAT I DON'T FEEL SAFE DRIVING IT.

Oct 01, 2016

BREAKING HARD, ESPECIALLY ON WET ROADS, THE FRONT WHEELS LOCK UP CAUSING LACK OF STEERING. NOTICED THIS AFTER PURCHASING THE VEHICLE NEW IN 2012. HAS HAPPENED MULTIPLE TIMES WITH NORMAL BRAKING AND EMERGENCY STOPPING.

Jan 28, 2016

ON SEPTEMBER 20, 2015, THE ABS AND TRACTION CONTROL LIGHTS CAME ON AND DIDN'T GO OFF. UPON INVESTIGATION, I DISCOVERED THAT THERE WAS IN FACT A RECALL ON THE 2012 TOYOTA TACOMA; HOWEVER, IT DID NOT INCLUDE MY VIN NUMBER. I CONTACTED BOTH OUR LOCAL DEALERSHIP AND TOYOTA DIRECTLY AND WAS TOLD THAT THERE WERE NOT ANY PLANS AT THIS TIME TO EXPAND THE RECALL TO INCLUDE MY VEHICLE. I CAN NOT TELL IF THESE COMPONENTS ARE WORKING OR NOT AS I HAVE NOT DRIVEN IN ICE, SNOW, ETC AND HAD A NEED FOR THEM TO ENGAGE. BUT AT THE SAME TIME, I DON'T WANT TO WAIT UNTIL A TIME IN WHICH I DO NEED THEM AND THEY BE INOPERABLE.

Sep 21, 2015

BRAKE FAILURE THINKING DUE TO WEAR AND TEAR-- BRAKES SERVICED -- NEW BRAKE PADS ON FRONT BACK PADS STILL GOOD -- BRAKE CYLINDER HAD TO BE REPLACED ON FRONT PASSENGER SIDE -- BRAKES BLED OFF STILL NO BRAKES ONLY HAVE BRAKES IF PUMP THEM CONTINUOUSLY -- AT THE MOMENT STILL IN SHOP TRYING TO FIND A MASTER CYLINDER TO REPLACE THE ONE IN IT TO SEE IF THAT WILL FIX THE PROBLEM

Jun 05, 2015

CONSTANT SQUEAL/YELP WHEN COMING TO A COMPLETE STOP COMING FROM REAR BRAKES. *TR

Jul 04, 2014

+ 4 more complaints for this component

STEERING

8 complaints

While driving on the road truck locks up occassionally in a curve. i know of mulitple trucks its happening to and only in curves- will end up hurting someone if a fix for it isnt found - no one seems to know what is going on

May 22, 2025

Sudden and total loss of power steering while backing up to park. There were/are no warning lights or messages displayed on the dashboard. With great difficulty, I was able to drive the car to my local mechanic. Steering was extremely difficult. The power steering unit has been ordered by my mechanic.

Aug 08, 2023

RECENTLY I HAVE NOTICED THE STEERING ON MY 2012 TACOMA IS HARDER THAT NORMAL AND NO LONGER RETURNS TO CENTER AFTER TURNING. UPON INVESTIGATING ONLINE AND VISUALLY INSPECTING MY TRUCK, THE INTERMEDIATE STEERING ROD LOWER BALL JOINT HAS FAILED! UPON VISUAL INSPECTION IT APPEARS THAT THE CUPS AND BEARING ARE DESTROYED . TOYOTA CONSIDERS THIS A NORMAL WEAR ITEM!! THE TRUCK ONLY HAS 34,400 MILES ACTUALLY THIS IS A DANGEROUS SITUATION THAT WILL SOMEDAY RESULT IN INJURY OR DEATH AND SHOULD BE TAKEN SERIOUSLY BY TOYOTA. IT APPEARS THAT MANY TOYOTA OWNERS ARE EXPERIENCING THE SAME ISSUE FOR MANY YEARS.

Mar 11, 2021

TL* THE CONTACT OWNS A 2012 TOYOTA TACOMA. THE CONTACT STATED THAT AFTER MAKING A TURN, THE STEERING FAILED TO RETURN TO THE CENTER POSITION AUTOMATICALLY. THE CONTACT STATED THAT THE STEERING CEASED IN THE TURNED POSITION. THE CONTACT STATED THAT ADDITIONAL EFFORT WAS NEEDED TO CORRECT THE FAILURE. VANDERSTYNE TOYOTA LOCATED AT (4374 W RIDGE RD, ROCHESTER, NY 14626, 585-225-6600) WAS CONTACTED AND INFORMED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT SUBJECTED TO A RECALL. THE VEHICLE WAS REPAIRED AT A COST OF $550 OUT OF POCKET. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT OFFERED NO ADDITIONAL ASSISTANCE. THE FAILURE MILEAGE WAS 75,000. *BF*JB

Mar 30, 2020

MY STEERING SHAFT ROTTED AND SEIZED. I TOOK IT TO A DEALER AND THEY REPAIRED IT BUT CHARGED ME $536.02 TO FIX IT. WHEN I RESEACHED RECALLS THERE WAS ONE ON 5/12/12. I AM ASKING FOR MY MONEY BACK FOR THIS REPAIR

Dec 27, 2018

+ 3 more complaints for this component

ELECTRICAL SYSTEM

6 complaints

HORN WILL NOT WORK WITH THE STEERING WHEEL CENTERED. IF YOU TURN THE STEERING WHEEL TO THE LEFT OR RIGHT AND PUSHING THE HORN IT WILL WORK. TOYOTA ISSUED A RECALL FOR THIS PROBLEM ON 2005-2009 TACOMA BUT NOT FOR THE 2012. TOYOTA HAS KNOWN THAT THEY HAVE A PROBLEM WITH THE CLOCK SPRING THAT THEY WON'T ADDRESS ON THE 2012'S.

Jan 06, 2021

DEFECTIVE CLOCK SPRING. OPEN CIRCUIT.

Jun 10, 2019

MY 2012 TACOMA HAS A SPIRAL WIRE ISSUE THAT DEALER REFUSES TO FIX EVEN THOUGH THIS PART IS ASSOCIATED WITH THE TAKATA RECALL IN PREVIOUS YEAR MODELS WONDERING WHY THE RECALL STOPPED AT 2011 AND DOES NOT COVER THE ISSUE WITH MY TRUCK. CURRENTLY ONLY AFFECTIN THE USE OF MY HORN BUT AS SEEN IN PREVIOUS RECALLS COULD AFFECT MORE LTHINGS LATER ON.

May 16, 2017

HORN STOPPED WORKING A COUPLE OF YEARS AGO. MY RESEARCH SHOWED IT WAS SAME PROBLEM WITH 2010 TACOMA'S,AND THEY WERE RECALLED! READ THERE WAS A RECALL TO REPLACE A DEFECTIVE SPIRAL CABLE IN STEERING WHEEL. CALLED TOYOTA WAS TOLD TO TAKE TO DEALER, BUT WOULD HAVE TO PAY,AND MAYBE BE REIMBURSED. DON'T HAVE THE MONEY BEEN UNEMPLOYED FOR 4 YEARS.

Mar 03, 2017

SECONDARY AIR INJECTION VALVE STUCK CODES P2440,P2442. TRUCK GOES INTO LIMP MODE AND YOU CAN ONLY GO A MAX OF 40 MPH.TOYOTA KNOWS ABOUT THESE ISSUES AND DOES NOTHING ABOUT IT

Dec 29, 2016

+ 1 more complaint for this component

WHEELS

5 complaints

The contact owned a 2012 Toyota Tacoma. The contact stated that while his son was driving 40 MPH, the rear driver-side wheel rim detached. The traction control and ABS warning lights were illuminated. The vehicle veered to the right, accelerated independently, and went up the embankment, hit a tree, and accelerated independently down the embankment when the vehicle flipped on the passenger side, where it came to a stop. The driver-side and passenger-side air bags deployed, and the side curtain air bags deployed. A police report was not filed. There were no injuries sustained. The vehicle was towed to an independent mechanic but was not diagnosed or repaired. The insurance company was contacted, and pending results. The manufacturer was not made aware of the failure. The failure mileage was unknown. The VIN was not available.

May 15, 2025

Crash: 1

NEED UPDATED OVERLAY LABEL ON THE TIRE AND LOADING INFORMATION LABEL ACCORDING TO FMVSS 110 S4.3. NHTSA RECALL NUMBER 14V475. MANUFACTURER RECALL NUMBER: E0X. NO ACCIDENT OR ABNORMALITY OCCURED

Apr 20, 2017

TREAD CRACK/SPLIT OR DRYROT ON OUTER AND INNERMOST TREAD SURFACE OF ALL FOUR TIRES. BOUGHT VEHICAL USED WHEN IT HAD 44,627 MILES WHEN NOTICING THIS PROBLEM.

Feb 01, 2017

CHANGING A FLAT TIRE, THE SPARE WHICH HAS NEVER BEEN USED WAS LOW ON AIR, DROVE FOR LESS THAN 5 MILES AND PARKED LATER IT WAS FLAT TOO.DEALER HAS DONE SEVERAL MULTI POINT INSPECTIONS, SPARE TIRES NOT ON LIST. DEALER STOLE THE HUBCAP DURING THE MOUNTING / INSTALLATION

Nov 06, 2015

TL* THE CONTACT OWNS A 2012 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THERE WAS A LOUD NOISE HEARD FROM UNDER THE VEHICLE. THE CONTACT LOOKED IN HIS REAR VIEW MIRROR AND SAW THAT THE SPARE TIRE WAS ROLLING DOWN THE STREET. THE CONTACT IMMEDIATELY PULLED OVER AND RETRIEVED THE TIRE. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS WHERE THEY ADVISED HIM THAT THEY WERE UNSURE AS TO WHY THE TIRE SEPARATED FROM THE VEHICLE. THE VEHICLE WAS REPAIRED BY RE-INSTALLING THE SPARE TIRE UNDER THE VEHICLE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 9,700.

Dec 28, 2012

POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE

5 complaints

DURING NORMAL DRIVING, THE CHECK ENGINE LIGHT AND TRACTION CONTROL OFF LIGHT CAME ON AND TRUCK IMMEDIATELY WENT IN TO LIMP-HOME MODE. I HAD IT SCANNED FOR CODES AT THE LOCAL AUTO PARTS STORE AND IT CAME BACK WITH P2440 AND P2442 WHICH SEEMS LIKE A COMMON ISSUE WITH A VALVE IN THE SECONDARY AIR INJECTION SYSTEM. I QUICK GOOGLE SEARCH SHOWED THAT SOME 2012 TACOMA OWNERS ARE GETTING THIS COVERED UNDER A SPECIAL WARRANTY EXTENSION, SO I PUTTERED OVER TO THE TOYOTA DEALERSHIP EXPECTING TO HEAR THE SAME STORY, BUT THEY ARE TELLING ME THE ECM COMPUTER IS BAD. WHICH I AM TRYING TO GET CLARIFICATION ON SINCE I CAN'T FIND ANY ECM FAILURE ISSUES FOR THIS MAKE AND MODEL YEAR.

Apr 05, 2019

WHILE COMMUTING TO WORK THE ENGINE LIGHT AND TRACTION CONTROL LIGHT CAME ON, CAUSING MY TRUCK TO SLOW DOWN, VERY SLOW. IT WOULD NOT LET ME ACCELERATE AND DISABLED MY PROGRESS TO AROUND 2000 RPMS. THIS COULD HAVE BEEN A VERY SERIOUS OR A DANGEROUS SITUATION ESPECIALLY IF I WAS TOWING A LOAD OR IN A MAJOR TRAFFIC SITUATION. CODES - 2440 AND 2442 WERE THE CAUSES OF THIS SCARY ACCOUNT.

Sep 02, 2017

CODE P2440 AND P2442. AIR INJECTION SYSTEM VALVES ARE STUCK OPEN (RELATED TO EMISSIONS CONTROL UNIT) WHICH CAUSES THE VEHICLE TO GO INTO 'LIMP' MODE ABRUPBTLY. THIS RENDERS THE VEHICLE UNDRIVEABLE, AND CAN OCCUR IN THE MIDST OF DRIVING CAUSING SERIOUS DANGER TO THE DRIVER AND FELLOW DRIVERS ON THE ROAD. TOYOTA IS UNWILLING TO COVER UNDER ANY POWERTRAIN OR EMISSIONS WARRANTY. THIS ISSUE IS PERVASIVE AMONG 2012 TACOMA OWNERS AND TOYOTA REDESIGNED THE SYSTEM AS EARLY AS 2013 WHICH IMPLICATES THEIR KNOWLEDGE OF SUCH A DEFECT.

Feb 26, 2017

CHECK ENGINE LIGHT CAME ON, TRAC OFF LIGHT IS ON. MY TRUCK HAS NO POWER AND IS UNSAFE TO DRIVE. THE DTC IS P2442. SECONDARY AIR INJECTION SYSTEM SWITCH VALVE STUCK OPEN BANK 2. TOYOTA KNOWS THEY HAVE A EMISSIONS ISSUE. MY VEHICLE IS AT THE DEALERSHIP NOW.

Nov 29, 2016

TACOMA WENT IN "LIMP MODE" ENGINE LIGHT AND TRAC OFF LIGHT ILLUMINATED; CAUSE THE CAR TO BE EXTREMELY UNDER POWER. VEHICLE EXTREMELY UNDER POWER CAUSING TO BE DANGEROUS IN TRAFFIC. CODE P2442 SECONDARY INJECTION SYSTEM FAILURE; COMMON TO OTHER TOYOTA VEHICLES INCLUDING TUNDRA'S. TOYOTA ACTED RESUMABLE WITH TUNDRA'S WITH EXTENDING WARRANTY REPAIRING BUT AT THIS TIME REFUSES TO REPAIR KNOWN FAILURES IN TACOMA'S.

Sep 20, 2016

UNKNOWN OR OTHER,ENGINE

5 complaints

AT LESS THEN 50K MILES ON THE ODOMETER AND 900 MILES FROM HOME MY TRUCK DECIDED TO GET A CHECK ENGINE LIGHT AND TRAC OFF LIGHT CAUSED BY CODES P2440 AND P2442 AND P2445. MERRY CHRISTMAS TO ME. THESE CODES PUT ME INTO LIMP MODE WHILE ON THE FREEWAY IN SNOWY AND ICY CONDITIONS. I COULD NOT MAINTAIN SPEED WITH THE FLOW OF TRAFFIC AS I WAS TRYING TO GET TO THE SHOULDER WITH TRAFFIC ZOOMING ALL AROUND ME, DANGEROUS AND SCARY! TOYOTA WANTS $2000 TO REPAIR IT. INTERNET RESEARCH HAS SHOWN ME THAT IT IS A COMMON PROBLEM THAT TOYOTA FAILS TO RECOGNIZE FOR TACOMAS BUT HAS ISSUED A TSB AND EXTENDED WARRANTIES FOR TUNDRAS. SHAME ON TOYOTA. NOW I GET TO ENDURE THE COST OF REPAIR AFTER THE HOLIDAY SEASONS AND I'M SURE MY BOSS WILL LOVE TO HEAR I WONT BE RETURNING TO WORK ON TIME.

Dec 26, 2017

I WAS PULLING OUT ON TO THE HIGHWAY AND MY TRUCK FAILED TO EXCEED 30 MPH WITH ONCOMING TRAFFIC WHICH NEARLY CAUSED AN ACCIDENT. UPON INSPECTION BY MY TOYOTA DEALERSHIP, THEY EXPLAINED THAT MY SECONDARY AIR INJECTION VALVES WERE STUCK OPEN (P2440, P2442) WHICH CAUSED THE TRUCK TO LOSE ALL POWER. I WAS THEN TOLD THAT SINCE I AM NO LONGER UNDER WARRANTY (MY TRUCK IS ONLY 5 YEARS OLD WITH 48,000 MILES ON IT) THAT TOYOTA WOULD NOT COVER THE 2,000 DOLLAR COST TO HAVE THE PART REPLACED. UPON FURTHER RESEARCH, COUNTLESS OTHERS WERE HAVING THE SAME ISSUE. THE TOYOTA TUNDRA ALSO HAD THIS ISSUE AND AN EXTENDED WARRANTY WAS OFFERED FOR THOSE VEHICLES. SINCE TOYOTA KNOWS THIS IS AN ISSUE IT IS MY BELIEF THAT THEY SHOULD STAND BY THEIR PRODUCT AND FIX THE DEFECTIVE PART WHICH IS A HUGE SAFETY ISSUE AS I FOUND OUT. FURTHERMORE, THERE IS NO REASON THIS EMISSIONS PART SHOULD EVER SHUT DOWN THE POWER TO THE TRUCK WHILE DRIVING. THANK YOU FOR YOUR TIME.

Sep 28, 2017

HEADED TO WORK TO FIND CHECK ENGINE LIGHT ILLUMINATED. TRUCK HAS LESS THAN 41,000 MILES. WENT TO AUTOZONE, CODE READER PROVIDED P2442 AND P2440 ERRORS RELATED TO THE SECONDARY AIR INJECTION SYSTEM VALVES. FOLLOWED UP WITH LOCAL TOYOTA DEALER. DEALER RAN DIAGNOSTIC AND FOUND SECONDARY AIR INJECTION SYSTEM VALVES STUCK OPEN IN BANKS 1 AND 2. DEALER WANTS TO REPLACE PARTS 17600-0P040: PUMP ASSEMBLY; 25710-31022: VALVE ASSEMBLY; AND THE 4 RELATED GASKETS, PART 17377-31010. QUOTE WAS FOR ALMOST $2400. AGAIN, THE VEHICLE IS 2012, LESS THAN 41K MILES! RESEARCHING THE TACOMA FORUMS ONLINE, THIS APPEARS TO BE A COMMON PROBLEM WITH THIS GENERATION MODEL AND MORE EVEN MORE SO WITH 2012'S. ONE OF THE DEALER'S SERVICE ADVISORS INFORMED ME THAT THIS IS ALSO A COMMON PROBLEM WITH TUNDRAS. FURTHERMORE, WHILE DRIVING, THE VEHICLE WOULD GO IN AND OUT OF "LIMP MODE" AND I HAD NO WARNING AS TO WHEN IT WOULD OR WOULD NOT BE IN THIS MODE, OTHER THAN BY THE WAY THE VEHICLE WAS HANDLING. LIMP MODE WOULD ONLY ALLOW TRANSMISSION TO SHIFT INTO 2ND OR 3RD AND NO MORE THAN 30 MPH, LESS IF CLIMBING AN INCLINE. AT OTHER TIMES, VEHICLE WOULD DRIVE NORMALLY. THE SWITCHING IN AND OUT OF THIS PROTECTIVE MODE SEEMS PARTICULARLY DANGEROUS. *TR

Dec 29, 2016

AFTER STARTING TACOMA, CHECK ENGINE LIGHT AND "TRAC OFF" LIGHT CAME ON, WENT INTO LIMP MODE, COULD ONLY GO 30MPH. TACOMA JUST HIT 34,000 MILES. DEALERSHIP STATED SECONDARY AIR INJECTION VALVE STUCK CLOSED BANK 1 (CODE P2441). WAS TOLD PUMP AND VALVES NEEDED TO BE REPLACED AT $2100, INCLUDING LABOR. CALLED TOYOTA CORPORATE, TOLD IT WAS NOT COVERED UNDER POWER TRAIN OR EMISSIONS WARRANTY. THIS ISSUE ACTUALLY FIRST OCCURRED APPROXIMATELY 4 MONTHS AGO WHILE DRIVING ON A CITY STREET. WARNING LIGHT CAME ON AND WENT INTO LIMP MODE. PULLED INTO A FIRESTONE AND THEY SAID IT WAS ALSO CODE P2441. THEY RESET IT AND IT DIDN'T HAPPEN AGAIN UNTIL A FEW DAYS AGO. THIS TIME THE CODE WOULD NOT RESET, WARNING LIGHT WON'T TURN OFF AND REMAINS IN LIMP MODE.

May 17, 2016

SECONDARY AIR INJECTION VALVE FAILURE AT 53K MILES, TOYOTA WOULD NOT COVER UNDER MY POWER TRAIN OR EMISSION WARRANTY. TRUCK WAS PUT INTO LIMP MODE WHEN THE FAILURE HAPPENNED AND WAS UNDRIVABLE.

May 11, 2016

AIR BAGS

5 complaints

REAR PASSENGER DOOR DOES NOT HAVE WELDED IN WINDOW STOPS. GLASS COULD SHATTER AND AIRBAG COULD DEPLOY.

Oct 03, 2015

THE AIR BAG WARNING LIGHT HAS COME ON TWICE WHILE DRIVING MY TACOMA. THE FIRST TIME I WAS DRIVING ON THE FREEWAY AND THE SECOND TIME I WAS DRIVING ON CITY STREETS. AS SOON AS I STOP THE VEHICLE AND UNBUCKLE THE SEAT BELT THE LIGHT GOES OFF. THE LOCAL TOYOTA DEALER DID A DIAGNOSTIC CHECK AND TEST DRIVE BUT THEY COULD FIND OR DUPLICATE THE PROBLEM. THEY SAID THERE IS NO RECALL ON THE VEHICLE, WHICH I HAVE ALSO VERIFIED.

Sep 26, 2015

TL* THE CONTACT OWNS A 2012 TOYOTA TACOMA. WHILE DRIVING AT APPROXIMATELY 35 MPH, THE CONTACT'S VEHICLE CRASHED INTO THE SIDE OF ANOTHER VEHICLE CAUSING SIGNIFICANT DAMAGE TO THE FRONT END. THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 29,000. UPDATED 8/10/15*CN THE CONSUMER STATED THE REPAIR COST APPROXIMATELY $10,000. UPDATED 11/24/2015*JS

Jun 09, 2015

Crash: 1

DRIVER SIDE AIRBAG NOT DEPLOY WHEN TRUCK HIT TELEPHONE POLE TRUCK TOTALED. *TR

Jun 26, 2013

Crash: 1

Injuries: 1

TL* THE CONTACT OWNS A 2012 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, HE CRASHED INTO A TREE AND THE AIR BAGS FAILED TO DEPLOY. THE CONTACT STATED THAT THE VEHICLE WAS DESTROYED BUT THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO A BODY SHOP. THE CAUSE OF THE FAILURE WAS UNKNOWN. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 20,000.

Nov 08, 2012

Crash: 1

ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES

4 complaints

BRAKES ACTUATE ABNORNMAL. BRAKES ENGAGE APPROX. 2 SECONDS AFTER THEY ARE APPLIED. BRAKES ALSO WILL COME ON AT FULL FORCE LOCKING THE VEHICLE UP. MASTER TECH DIAGNOSTIC - FAULTY BRAKE BOOSTER. TOYOTA HAS RECALLS FOR 2012 TACOMA'S HOWEVER MY VIN IS NOT INCLUDED IN RECALL.

Nov 07, 2019

THE ABS ACTUATES PREMATURELY DURING CORNERING ON FREEWAY ON/OFF RAMPS AND IN CORNERS RESULTING IN SUSPENSION DIVE, AN UNDER STEER CONDITION, AND LOSS OF VEHICLE CONTROL. THIS OCCURS WHEN THE VEHICLE IS IN MOTION AT POSTED SPEED LIMITS ON DRY PAVEMENT. I HAVE CONTACTED TOYOTA/BEEN TO THE DEALERSHIP SEVERAL TIMES ABOUT THIS ISSUE WITH NO RESOLUTION. THEY CLAIM THAT THE LEVELING KIT AND AT TIRES ARE TO BLAME. I RELATED THAT I HAD THIS ISSUE WITH THE TRUCK WHEN IT WAS BRAND NEW WITH NO MODIFICATIONS.

Sep 02, 2017

ABS GOES OFF UNEXPECTEDLY IN LOW SPEEDS/HIGH SPEEDS...DRY/WET CONDITIONS...USUALLY ON WINDING ROADS WITH GRADE FLUCTUATIONS CAUSING VEHICLE TO SLIDE INTO ONCOMING TRAFFIC. THIS HAS BEEN GOING ON SINCE MY PURCHASE IN 2012. THANKFULLY I HAVE NOT BEEN IN AN ACCIDENT DUE TO THIS BUT LOTS OF CLOSE CALLS. TOYOTA REFUSES TO RESOLVE THIS ISSUE, AND DENYS THAT IT HAPPENS.

Mar 19, 2016

BRAKES ON VEHICLE LOCK-UP AND ARE OVERLY SENSITIVE. ON MANY OCCASIONS WHEN DRIVING ON WET PAVEMENT AT SLOWS SPEEDS THE ABS ENGAGED AND LOCKED THE BRAKES WITH ONLY VERY LIGHT PRESSURE ON THE BRAKE PEDAL. ON ONE OCCASION WHEN DRIVING AT 10-15 MPH IN A PARKING LOT IN SNOW, A LIGHT TOUCH TO THE BRAKE LOCKED UP THE BRAKES CAUSING THE VEHICLE TO BECOME UNSTABLE AND CRASH. I HAVE HAD FOUR OTHER TOYOTA TRUCKS, THREE OF THEM TACOMAS AND NONE OF THEM HAD THIS BRAKING ISSUE. BARELY PRESSING THE BRAKES SHOULDN'T CAUSE THEM TO LOCK UP WHICH CAUSES THE VEHICLE TO BECOME VERY UNSTABLE. LUCKILY IT DOES IT MORE OFTEN AT LOW SPEEDS. IT'S A MAJOR SAFETY CONCERN AS THE VEHICLE BECOMES UNDRIVABLE.

Dec 24, 2015

Crash: 1

VEHICLE SPEED CONTROL,ENGINE

4 complaints

I WAS ON THE THE HIGHWAY TODAY AND SUDDENLY I LOST POWER AND WON'T PASS SPEEDS OVER 40 MPH VERY DANGEROUS HAVE HEARD THIS HAPPEND TO A LOT OF TACOMAS/ TUNDRAS AND HAS TO DO SOMETHING WITH THE EMISSIONS I THINK I NEED A NEW DIVERTER VALVE WHICH TOYOTA SHOULD COVER

May 02, 2019

TL* THE CONTACT OWNS A 2012 TOYOTA TACOMA. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE LOST POWER AND THEN IMMEDIATELY REGAINED POWER. THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED TWICE. THE CONTACT COASTED THE VEHICLE TO A SERVICE STATION, RESTARTED IT, AND WAS ABLE TO DRIVE. WHILE DEPRESSING THE ACCELERATOR PEDAL, THE VEHICLE WOULD NOT ACCELERATE PAST 25 MPH. THE VEHICLE WAS TAKEN TO TOYOTA OF POWAY (13631 POWER RD, POWAY, CA 92064) WHERE IT WAS DIAGNOSED THAT THE AIR SYSTEM VALVE NEEDED TO BE REPLACED. THE CONTACT WAS ALSO INFORMED THAT THE AIR INJECTION PUMP MAY EVENTUALLY NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS REFERRED TO NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 133,472.

Jan 31, 2018

2012 TACOMA WITH 91,000 MILES: WHILE LEAVING WORK AND TRYING TO ACCELERATE ONTO HIGHWAY THE "CHECK ENGINE" AND "TRAC OFF" LIGHTS ILLUMINATED. VEHICLE WENT INTO "LIMP MODE" AND WOULD NOT GO FASTER THAN 35 MPH. I HAD TO QUICKLY PULL OFF THE ROAD AS TO NOT CAUSE AN ACCIDENT. I TOOK VEHICLE TO MAC HAIK TOYOTA AND RECEIVED THE CODE P2445. I HAD TO REPLACE AIR SWITCH VALVE ASSEMBLY $690, AIR W/BRA PUMP ASSEMBLY $813, AIR TUBE GASKETS $132, LABOR $610. TOTAL $2063!!!! FROM RESEARCHING, THIS IS A KNOWN PROBLEM WITH 2012 TACOMAS, AND HAD PREVIOUSLY BEEN AN ISSUE WITH OLDER TUNDRAS, WHICH TOYOTA ISSUED A TSB FOR. TOYOTA REFUSES TO REPAIR THIS UNDER WARRANTY (FEDERAL EMISSIONS) EVEN THOUGH THE FAILED PART IS DIRECTLY TIED TO THE EMISSIONS SYSTEM! "THE SYSTEM IS USED TO PUMP ADDITIONAL AIR INTO THE EXHAUST MANIFOLD UPON STARTUP TO DILUTE THE OVER-RICH CONDITIONS THAT LEAD TO INCREASED POLLUTION. (HOW IS THAT NOT AN EMISSIONS RELATED PART?) THE FAILURE OR WARPING OF THE ONE-WAY CHECK VALVE CAUSES HOT EXHAUST GASES TO BACKFLOW INTO THE SOLENOID, AND MELTING THE GASKETS. THIS ENDS UP BLOCKING THE SEALING PLATE AND CAUSING IT TO REMAIN IN THE OPEN POSITION. THE DANGER IS THAT THE HOT EXHAUST IS THEN FED INTO A PLASTIC AIR PUMP CAUSING IT TO POTENTIALLY MELT OR CATCH FIRE!" THE FACT THAT THIS FORCES THE VEHICLE INTO "LIMP MODE" IS ALSO A HUGE SAFETY CONCERN AS IT WILL NOT ALLOW THE VEHICLE TO TRAVEL ABOVE 35 MPH AND COULD LEAD TO SERIOUS ACCIDENTS IF TRAVELING AT HIGH SPEED ON THE INTERSTATE OR HIGHWAY DUE TO THE UNEXPECTED, SUDDEN DECELERATION. FAILED ASSEMBLY IS TOYOTA PART NUMBER : 25710-31020. THIS PART NUMBER HAS BEEN SUPERSEDED BY P/N: 25710-31022. *TR

Jan 09, 2017

AFTER DRIVING FOR 2 HOURS AT HIGHWAY SPEED (65) MPH I EXITED THE HIGHWAY TO A INTERSECTION WITH A RED LIGHT. UPON APPLYING THE BRAKES TO COME TO A STOP THE VEHICLE ACCELERATED FORWARD ON ITS OWN. I WAS ONLY ABLE TO STOP A COLLISION BY PUTTING THE TRUCK INTO NEUTRAL . I COULD NOT STOP THE VEHICLE BY ONLY USING THE BRAKES. THE ENGINE OVER REVOLUTIONS BUT CAME BACK TO A IDLE IN JUST A FEW SECONDS. I HAVE NOT EXPERIENCED THIS IN THE PAST TWO YEARS THAT I HAVE OWNED THIS VEHICLE. I WAS NOT TOWING ANYTHING AND THE VEHICLE WAS NOT LOADED WITH ANY ADDITIONAL WEIGHT. I AM THE ONLY DRIVER. I CONTINUED ON WITH MY TRIP AND HAVE NOT EXPERIENCED THIS AGAIN AS OF THIS DATE. 02/20/2014 *TR

Feb 20, 2014

ELECTRICAL SYSTEM,ENGINE

4 complaints

THE CHECK ENGINE LIGHT AND THE TRAC OFF LIGHT CAME ON AS I WAS MERGING ONTO THE INTERSTATE. I IMMEDIATELY STOPPED THE VEHICLE, PULLED OVER, AND TOOK MY 2012 TOYOTA TACOMA WITH 78,000 MILES TO THE MECHANIC WHERE I LEFT IT OVERNIGHT FOR THEM TO LOOK AT IT IN THE MORNING. RUNNING A DIAGNOSTIC THEY FOUND CODE P2443 - SECONDARY AIR INJECTION SWITCHING VALVE STUCK. I ASKED IF THEY HAD DEALT WITH THIS BEFORE AND THEY SAID THIS IS A COMMON PROBLEM FOR TOYOTA AND THEY HAVE DONE RECALLS ON BOTH THE TUNDRA AND SEQUOIA MODELS THAT HAVE HAD THESE ISSUES, BUT THE TACOMA HASN'T HAD A RECALL YET, EVEN THOUGH IT SEEMS TO BE JUST AS COMMON WITH THE SAME PARTS. THEY SAID THE COST OF PARTS AND LABOR WOULD BE AROUND $2,000. WHEN I ASKED THEM IF THE VEHICLE WAS SAFE TO DRIVE OFF THEIR LOT THEY SAID THESE CODES CAN CAUSE THE TACOMA TO GO INTO "LIMP MODE" WHERE YOU CAN LOOSE POWER, ACCELERATION, AND WON'T BE ABLE TO GO OVER 45MPH. I HATE TO THINK WHAT COULD HAVE HAPPENED IF I HAD KEPT MERGING ONTO THE INTERSTATE AND TRIED TO GET UP TO SPEED ONLY TO "LIMP" INTO TRAFFIC OR IF THIS HAD HAPPENED A MINUTE LATER ON THE INTERSTATE! EVERY THREAD I READ ONLINE FROM MULTIPLE SOURCES SHOW PEOPLE HAVING SIMILAR ISSUES FROM AS LOW AS 1,000 MILES ON THE TRUCK. THE ISSUES WITH THE SECONDARY AIR INJECTION PUMP AND SWITCHING VALVES SEEMS MOST COMMON BETWEEN 50,000-80,000 MILES, BUT EVENTUALLY DOES HAPPEN IN THE 2012-2015 TOCOMA MODELS.

Jan 05, 2018

SECONDARY AIR INJECTION VALVE STUCK OPEN CAUSING LIMP MODE. HAPPENED NEAR VERY DANGEROUS INTERSECTION AND LOST ALL POWER IN TRUCK. AS OTHERS HAVE STATED, TRUCK ONLY HAS 50K MILES AND REQUIRED A $500+ REPAIR (PART ONLY) FOR A COMPONENT OF THE EMISSION SYSTEM WHICH IS ONLY USED ON STARTUP AND INCLUDES A WARRANTY OF ONLY 2 YEARS.

Feb 16, 2017

ENGINE/ALL POWER IS LOST WHEN ENGINE HAS REACHED A CERTAIN RPM. CODE READER STATES "CRANKSHAFT POSITION SENSOR "A" CIRCUIT MALFUNCTION".

Jan 16, 2017

WHEN I WAS LEAVING WORK THE OTHER NIGHT MY 2012 TACOMA WENT INTO LIMP MODE AND PRESENTED THE CEL AND TRAC OFF LIGHTS ON THE DASH. AFTER REVIEWING THE MANY BLOGS ON THE SUBJECT AND TAKING THE VEHICLE TO THE MECHANICS, I HAVE FOUND OUT THAT THE SECONDARY AIR VALVE IS LIKELY STUCK IN THE OPEN POSITION. THE MECHANIC HAS QUOTED ME A PRICE OF $1,142 ($780 FOR THE PART) TO REPLACE THE WHOLE SYSTEM (VALVE NOT SOLD SEPARATELY). I UNDERSTAND THAT THIS IS A COMMON PROBLEM WITH TUNDRAS/SEQUOIAS AND 2012 TACOS. HOWEVER, ONLY THE TUNDRAS ARE UNDER ANY TYPE OF WARRANTY. I BOUGHT A TACOMA BECAUSE THE LAST TWO TOYOTA'S HAVE RUN 300K MILES + WITH REGULAR MAINTENANCE. THIS TYPE OF EXPENSIVE REPAIR DUE TO POOR ENGINEERING IS LUDICROUS AND SHOULD BE A WARRANTY ISSUE. I GUESS TOYOTA WANTS TO BE TERRIBLE LIKE EVERYONE ELSE. GREAT. *TR

Dec 18, 2016

VEHICLE SPEED CONTROL

4 complaints

TL* THE CONTACT OWNS A 2012 TOYOTA TACOMA. WHILE ATTEMPTING TO SWITCH THE VEHICLE TO FOUR WHEEL DRIVE, A LOUD ABNORMAL NOISE WAS HEARD. THE VEHICLE SUDDENLY ACCELERATED WITH THE BRAKE PEDAL DEPRESSED. THE CONTACT SHIFTED THE GEAR INTO NEUTRAL; HOWEVER, THE VEHICLE CONTINUED TO ACCELERATE. THE CONTACT WAS ABLE TO BRING THE VEHICLE TO A STOP BY DEPRESSING THE BRAKE PEDAL WITH FORCE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 42,000.

Jun 22, 2015

TL* THE CONTACT OWNS A 2012 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE COMING TO A STOP, THE VEHICLE ACCELERATED INDEPENDENTLY. THE FAILURE OCCURRED TWICE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR A DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 5,000.

Sep 25, 2014

TL* THE CONTACT OWNS A 2012 TOYOTA TACOMA. THE CONTACT STATED THAT THE ACCELERATOR PEDAL WAS DEPRESSED AND THE VEHICLE VIOLENTLY SURGED FORWARD. THE CONTACT WAS NOT ABLE TO CONTROL THE VEHICLE AND CRASHED INTO A TREE. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES TO THE NECK, THE BACK AND THE HANDS THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN. UPDATED 10/23/2014*LJ UPDATED 05/21/2015 *JS

May 30, 2014

Crash: 1

Injuries: 1

VEHICLE JUMPS FROM REAR UPON ACCELERATION FROM STOP POSITION. *TR

Feb 20, 2014

STRUCTURE

3 complaints

Under the bottom of my truck, there is tons of rust. I know a lot of the trucks my year, make, and model has been recalled for rust on the body and other parts of the truck. I was told that a Toyota dealership should replace it with the amount it has, and now a hole has appeared but they only told me a price to fix everything that is rusted. Just puts my vehicle at risk driving it back and forth to work.

Dec 18, 2023

WHILE DRIVING ON HIGHWAY 4/20/2018 THE RIGHT SIDE ROOF MOLDING CAME OFF AND FLEW IN TO CAR BEHIND ME,CAR DID NOT STOP. IT MADE A VERY LOAD NOISE AS IT CAME OFF. I WAS ON THE INTERNET AND SAW THERE WERE OTHERS WITH THIS ISSUE AND THERE WAS A RECALL ON THE 2008-2011 MODELS.

Apr 24, 2018

TL* THE CONTACT OWNS A 2012 TOYOTA TACOMA. THE CONTACT DISCOVERED THAT THE FRONT TOW END CAUSED EXTREME WEAR ON THE FRONT TIRES. THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 15,000.

Nov 19, 2014

ENGINE AND ENGINE COOLING

2 complaints

The contact owns a 2012 Toyota Tacoma. The contact stated that while driving, the vehicle failed to exceed 45 MPH. The contact stated that the check engine and traction control warning lights were illuminated. The vehicle was taken to an independent mechanic who informed him about a Special Service Campaign: 20TC01. The vehicle was taken to the local dealer where it was diagnosed and determined that the air injection pump needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and informed him that the Special Service Campaign: 20TC01 had expired. No additional assistance was provided. The failure mileage was approximately 85,000.

Aug 30, 2022

THE TRUCK STARTED TO MAKE A RATTLING NOISE UNDER THE HOOD ON THE DRIVERS SIDE WHEN REACHING 15MPH. TOOK IT TO DEALER TO HAVE IT EXAMINED. THEY SAID TO TRY DIFFERENT GAS NOT CHEAP GAS. "I WAS ALREADY USING SHELL GAS" BUT I DID WHAT THEY SAID. STILL MAKING THE NOISE NOW FROM 20-40MPH. TAKE IT BACK TO DEALER NOW THEY TAKE A TEST DRIVE WITH MYSELF TO VERIFY THE NOISE. COMES BACK THAT IT HAS A TAS CASE# THERE'S NOTHING THEY CAN DO ABOUT IT. I CALL TO FILE A COMPLAINT TO FIND OUT THERE IS NO REPAIR AND THEY WILL NOT TOUCH IT TILL IT BECOMES A RECALL. JUST TOOK IT BACK FOR THE THIRD TIME BECAUSE THE RATTLING IS LOUDER AND LONGER. STILL DID NOTHING. THE RATTLING CAN GET SO LOUD THAT IT SOUNDS LIKE SOMETHING IS GOING TO FALL OUT FROM UNDER THE HOOD. *TR

Aug 19, 2013

ELECTRICAL SYSTEM,UNKNOWN OR OTHER

2 complaints

HORN WILL NOT WORK WITH THE STEERING WHEEL CENTERED. IF YOU TURN THE STEERING WHEEL 90% TO THE LEFT OR RIGHT THE HORN HAS WORKED SOMETIMES. TOYOTA ISSUED A RECALL FOR THIS PROBLEM ON OTHER TACOMAS BUT NOT FOR THE 2012. THE TOYOTA DEALERSHIP IS SAYING THAT ITS MOST LIKELY THE CLOCK SPRING.

Jan 27, 2021

SUN VISOR , SPRING INSIDE VISOR BREAKS. MAKING THE VISOR HANG DOWN. WIRE HARNESS FROM AC BLOWER MOTOR, SO SOMEWHERE IN THE ENGINE COMPARTMENT OVERHEATS AND MELTS WIRING SO THE AIR CONDITIONING STOPS WORKING.

Nov 05, 2020

SUSPENSION,POWER TRAIN

2 complaints

WHEN I'M DRIVING THE TRUCK BETWEEN 30 AND 40 MILES AN HOUR THE TRUCK FEEL LIKE WANTS TO STOP AND SAUNDS WUIRD I THINK IS THE TORQUE CONVERTER IS NOT DOING HIS JOB PROPERLY ALSO THAT SUSPENSION IS GETTING RESTLESS SO BAD AND SO QUICKLY AND THE CHATS ARE SO HARD SO I DON'T KNOW IF IT IS SOMETHING WRONG WITH IT OR IT'S JUST NORMAL IN THE CAR AND SAW THE THINGS I'VE BEEN CHECKING ON IT 2012 TOYOTA AND I HAD IT FOR THREE YEARS ALSO IT TAKES TOO LONG TO HEAT UP IN WINTER TIME

Mar 09, 2020

AT 300 MILES I NOTICED UPON DOWNSHIFTING ( I BELIEVE 3-2 OR 2-1) A RUMBLESTRIP VIBRATION FEELING. I TOOK THE TRUCK TO THE DEALER AND THEY SAID IT WAS NORMAL. IT STILL OCCURS EVERYTIME I DOWNSHIFT (SOMETIMES STRONGER FEELING THEN OTHER TIMES) I RESEARCHED PREVIOUS YEARS WITH THE SAME COMPLAINT.. IT CANT BE HEALTHY FOR THE TRANSMISSION CLUTCHES. I NOW HAVE 1300 MILES...STILL HAPPENING...ANY THOUGHTS? *TR

Mar 06, 2012

ELECTRONIC STABILITY CONTROL (ESC)

2 complaints

TRAC OFF WARNING LIGHT CAME ON AUTOMATICALLY. THE VEHICLE WAS STATIONARY. I HAD TURNED CAR ON TO DRIVE DOWN THE HILL ON MY PROPERTY.

Apr 08, 2019

I WAS DRIVING ON THE FREEWAY, IN LIGHT RAIN. MY CAR RANDOMLY ENGAGED A SYSTEM THAT SLOWED MY VEHICLE DOWN. THIS RESULTED IN MY LOSING TRACTION WITH THE ROAD, MY TRUCK BEGAN TO HYDROPLANE. MY TRUCK SPUN AND MOVED TOWARDS THE HIGHWAY MEDIAN. THE MEDIAN HAD A V-DITCH, MY FRONT PASSENGER TIRE IMPACTED THE V-DITCH AND FLIPPED MY VEHICLE. IF IT WEREN'T FOR MY SEAT BELT LOCKING AND SIDE AIRBAGS DEPLOYING IT MAY HAVE BEEN A FATAL ACCIDENT. IT WAS A LIFE THREATENING ACCIDENT. *TR

Apr 06, 2014

Crash: 1

ELECTRONIC STABILITY CONTROL (ESC),ENGINE,FUEL/PROPULSION SYSTEM

2 complaints

THE SECONDARY AIR INJECTION SYSTEM WENT OUT

Mar 12, 2018

MY 2012 TOYOTA TACOMA PRERUNNER 2WD HAS 54,640 MILES. I JUST GOT A CHECK ENGINE LIGHT AND "TRAC OFF" LIGHT YESTERDAY. MY TRUCK WOULD ACCELERATE TO JUST 25 MPH WHEN MERGING ONTO THE INTERSTATE AND TOP SPEED WAS AROUND 50 MPH. THIS IS A SERIOUS SAFETY ISSUE AND TOYOTA WILL NOT COVER THIS KNOWN PROBLEM UNDER THE STANDARD 3 YEAR 36,000 MILE WARRANTY. AUTOZONE RAN THE DIAGNOSTIC SCAN AND CAME UP WITH TROUBLE CODES P2440 AND P2442. THESE ARE TIED TO THE SECONDARY AIR INJECTION SYSTEM AND SWITCHING VALVES. THE TOYOTA DEALERSHIP SAID THIS WOULD COST ME CLOSE TO $2000 TO REPAIR. I PAID $30,000 FOR THIS VEHICLE BRAND NEW JUST 4 YEARS AGO. THIS NEEDS TO BECOME A CLASS ACTION LAWSUIT SO THAT A SAFETY RECALL IS ISSUED FOR TOYOTA TO REPAIR THIS KNOWN DEFECT FOR FREE.

Jul 16, 2016

POWER TRAIN,FUEL/PROPULSION SYSTEM

2 complaints

CHECK ENGINE LIGHT AND TRAC OFF LIGHT CAME ON. TRUCK WENT INTO "LIMP" MODE AND WOULD ONLY GO ABOUT 35MPH. CHECKED THE ERROR CODE AND IT WAS P2442 WHICH SAYS THE SECONDARY AIR INJECTION SYSTEM IS FAILING. TRUCK HAS ONLY 55K MILES ON IT AND HAS BEEN REGULARLY MAINTAINED BY TOYOTA DEALERSHIPS EVERY 6 MONTHS / 5K MILES. DEALERSHIP HAS SAID IT WILL BE $2023 TO REPLACE THE SYSTEM. THERE SHOULD BE A RECALL OR EXTENDED WARRANTY ON THIS INJECTION SYSTEM

Nov 20, 2017

CHECK ENGINE LIGHT ON, TRAC OFF LIGHT ON, ENGINE POWER WEAK CHECK ENGINE CODE- P2441. THIS HAS BEEN A COMMON ISSUE WITH TOYOTA SUVS, AND TRUCKS! CAR IS PUT INTO LIMP MODE. EXTENDED WARRANTY ON TUNDRA WITH SAME PART PROBLEM. NOT TACOMA. SHAMEFUL AND DANGEROUS FOR TACOMA OWNERS.

Jul 27, 2017

POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM

2 complaints

I START UP THE TRUCK AND PULL OUT IN TO THE STREET. WHETHER AT AN INTERSECTION OR MAKING A TURN, I PUSH ON THE ACCELERATOR AND NOTHING HAPPENS. THE RPMS DON'T INCREASE, ENGINE MAKES NO SOUND - AND I AM LEFT SITTING IN THE MIDDLE OF THE ROAD. I PUSH THE ACCELERATOR TO THE FLOOR AND EVENTUALLY THE ENGINE COMES TO LIFE AND THE TRUCK MOVES FORWARD. HAPPENS MORE OFTEN THAN NOT WHEN THE VEHICLE IS "COLD" - WITHIN THE FIRST 20-30 MINUTES OF OPERATION. THE ACCELERATOR IS NOT LINKED DIRECTLY TO THE ENGINE THROUGH A CABLE BUT IS A DRIVE BY WIRE. I HAVE MAINTAINED MY TACOMA METICULOUSLY SINCE PURCHASE INCLUDING TUNE UPS, OIL CHANGES, ETC. I HAVE CLEANED THE MASS AIR FLOW SENSOR WITH NO CHANGE. THE PROBLEM STILL PERSISTS. IT IS VERY DANGEROUS TO BE IN THE MIDDLE OF AN INTERSECTION WITH A VEHICLE THAT HAS LOST POWER.

Oct 30, 2017

MY 2012 TACOMA WITH 45,000 MILES GOT A CHECK ENGINE LIGHT AND "TRAC OFF" LIGHT WHEN I STARTED IT TO GO HOME. I WAS MERGING ONTO THE INTERSTATE AND UNABLE TO GO ABOVE 40 MPH. THIS WAS OBVIOUSLY NOT SAFE SO I EXITED AND TOOK IT TO A DEALER. THEY CITED TROUBLE CODES P2440 AND P2442 AND SAID THEY NEEDED TO REPLACE SECONDARY AIR INJECTION VALVE (PN 25710-31022) FOR A TOTAL COST OF $940! ACCORDING TO FORUMS AND THE NHTSA.GOV SITE, THIS IS A VERY COMMON COMPLAINT WITH THIS YEAR AND MODEL. I JUST BOUGHT THIS LAST JULY AND I NEVER EXPECTED TO HAVE TO REPLACE PARTS ANYTIME SOON.

Jul 20, 2016

VEHICLE SPEED CONTROL,FUEL/PROPULSION SYSTEM

2 complaints

I TOOK MY 2012 TACOMA INTO SERVICE TODAY WITH A TRAC OFF AND CHECK ENGINE LIGHT ON. I WAS TOLD THAT THE SECONDARY AIR INJECTION SWITCHING VALVE NEEDED REPLACED AT THE TUNE OF $1300. I SEE THAT MANY OTHERS HAVE HAD THIS ISSUE AND WITH 37K MILES, I FIND IT UNREAL THAT THIS ISN'T COVERED UNDER THE POWERTRAIN WARRANTY.

Jun 28, 2016

MY TACOMA TENDS TO SURGE FORWARD WHEN IT IS STOPPED. I THINK IT HAS SOMETHING TO DO WITH THE AIR CONDITIONER BEING ON. IF SOMEONE ISN'T ON THE BRAKE FIRMLY THEY MAY TAP THE VEHICLE IN FRONT OF THEM. *TR

Aug 01, 2012

POWER TRAIN,ENGINE

2 complaints

VEHICLE LUNGES WHEN YOU COME TO COMPLETE STOP, BETTER HOLD THE BRAKE WITH SOME FORCE ANY TIME STOPPED, TOYOTA SERVICE SAYS IT HAPPENS ALL THE TIME, ITS NORMAL !!

Nov 06, 2015

AT APROXIMATE 40 MPH AND AT A CONSTANT SPEED THE VEHICLE STARTS TO SHUTTER OR SHAKE, FEELS LIKE IT WANTS TO DOWN SHIFT OR UP SHIFT MAYBE ITS CONFUSED. DEALER COULD NOT DUPLICATE 2 TIMES

Nov 06, 2015

SEAT BELTS

2 complaints

MY SEAT BELT REMINDER BUZZER DOES NOT WORK, IT HAS NOT CAUSED ANY TROUBLE BUT IT COULD IF I FORGET TO BUCKLE UP. I HAVE BEEN TO TWO DEALERS AND THEY SAY IT IS WORKING NORMALLY. *TR

Feb 22, 2014

THE CENTER SEAT BELT AUTOMATIC LOCKING RETRACTOR (ALR) WILL NOT RELEASE IF THE SHOULDER SEAT BELT IS COMPLETELY EXTENDED. THE OWNERS MANUAL SAYS THAT THIS IS NORMAL AND THAT WHEN THE SEATBELT IS FULLY RETRACTED IT WILL FREE IT UP. THIS DOES NOT WORK UNLESS THE SEAT IS ADJUSTED AT LEAST HALF WAY BACK. I AM 5'-9" TALL, AND HAVE THIS PROBLEM ABOUT 1/2 THE TIME. MY DAUGHTER WHO IS MUCH SHORTER, HAS THIS PROBLEM ALL THE TIME. I TOOK THIS TO THE DEALER, AND THEY CALLED TOYOTA TECHNICAL SUPPORT AND THEY SAID THAT THE SEAT BELT IS FUNCTIONING AS DESIGNED. IT SEEMS DANGEROUS TO ME TO NOT BE ABLE TO USE THE CENTER SEAT BELT UNLESS YOU SCOOT THE SEAT ALL THE WAY BACK, AND THEN PULL IT FORWARD EACH TIME YOU HAVE A PASSENGER IN THE MIDDLE SEAT. IT THIS IS IN FACT A PROPER WAY TO USE THE SEAT BELT THEY SHOULD AT LEAST PUT WARNING LABELS ON THE SEAT BELT EXPLAINING HOW TO GET IT TO OPERATE. IN MY OPINION, IT WOULD BE MUCH SAFER JUST TO HAVE A LAP BELT ONLY, RATHER THAN A SHOULDER BELT THAT IS VERY INCONVENIENT TO USE. *TR

Mar 14, 2012

POWER TRAIN,STRUCTURE,TIRES

1 complaint

The contact owns a 2012 Toyota Tacoma. The contact stated that the undercarriage of the vehicle was significantly rusted. The TPMS warning light was illuminated. The vehicle was taken to the local dealer, where it was repaired under the warranty; however, the failure recurred. The dealer informed the contact that the rear bumper and brackets were rusted, and there was no recall or warranty coverage. The contact stated upon pulling into the driveway of the residence, the contact noticed a trail of fluid leak on the street. The contact stated that the transmission lines were fractured due to rust. The vehicle was taken to an independent mechanic, where the contact was informed that the vehicle was significantly rusted. The vehicle was not repaired. The manufacturer was contacted and a case was filed. The failure mileage was approximately 71,000.

Jul 30, 2025

STRUCTURE,UNKNOWN OR OTHER,SERVICE BRAKES

1 complaint

Will not fix the frame. my husband has a 2005 and it looks new compared to my 2012. The last mechanic I used told me not to bring it back to him to much rust. Toyota said it passed their inspection. There is no way. They’ve had my truck almost a yr. I thought they was fixing it. No they just been chilling. They never called me to tell me it was they wouldn’t honor the recall. Nothing. I keep reading on here cold climate states are the only complaints. Someone is lying on here because I know at least 20 Toyota Tacoma owners from Texas who have filed incident reports.

Sep 24, 2023

Crash: 1

UNKNOWN OR OTHER,SERVICE BRAKES,FUEL/PROPULSION SYSTEM

1 complaint

My truck lost drivability while I was going 60 I ran into a ditch to stop. It hads two codes . I took it in they replaced my rack n pinion. Check engine light came on . Mechanic said he could not work on it anymore because of the rust. To much corrosion he would be risking liability for other parts getting damaged because of all the rust. Took it to mike Shaw to have frame tested. It passed they said. But I can’t find a mechanic to work on it but mike Shaw and they’ll just keep charging for each item they don’t care.

Dec 20, 2022

Crash: 1

SERVICE BRAKES, HYDRAULIC,ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

The contact owns a 2012 Toyota Tacoma. The contact stated that while driving at various speeds in areas with low traction, several unknown warning lights would illuminate on the instrument panel and the vehicle would begin to drift independently. Once the contact regained control of the vehicle, the warning lights would disappear, and the vehicle would resume normal operation. The contact had taken the vehicle to a dealer for repair. Upon investigation, the contact discovered NHTSA Campaign Number: 14V054000 (Service Brakes, Hydraulic, Electronic Stability Control) which he linked to the failure. Upon speaking with the dealer, the contact was informed that the vehicle was not included in the recall. The manufacturer was also notified of the failure and the contact was directed to the website for assistance. The vehicle remained in the possession of the dealer and had yet to be repaired. The failure mileage was approximately 85,500.

Sep 02, 2021

VEHICLE SPEED CONTROL,SERVICE BRAKES,ENGINE

1 complaint

June 1st 2021 I went to park in a parking space at a local mall. My truck instead of stopping it accelerated out of control jumped two stone curbs, drove though a fence and landed into a swamp. Call Toyota and they have opened a new case # 210602000065. Police report # 21-374-AC. This isn't the first time that this has happen with this truck. It happen in Aug 2019. I contacted Toyota case number 1908060035. They sent out EAA Engineering Analysis Ass. out who did a ACM.CDRX file a month later. Toyota came back said they couldn't find anything wrong and my case was closed. Another incident in winter of 2016 where my truck was stopped and it accelerated on its own and It drove in the 4 way intersection where it caused an accident. lots of damage to cars. Toyota was contacted and they sent me to a dealer for repairs. Dealership has records of my truck coming in since I owned it with complaints of Truck not moving at all to all of sudden to acceleration on its own.

Jun 02, 2021

Crash: 1

Injuries: 1

TRACTION CONTROL SYSTEM,SERVICE BRAKES

1 complaint

TL* THE CONTACT OWNS A 2012 TOYOTA TACOMA. THE CONTACT STATED WHILE DRIVING 80 MPH, WHILE THE BRAKE PEDAL WAS NOT BEING DEPRESSED, THE BRAKES LOCKED UP WHICH CAUSED THE VEHICLE TO START SLIDING. THE CONTACT STATED THAT THE TRACTION CONTROL WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT REPAIRED. UPON INVESTIGATION, THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 14V054000 (SERVICE BRAKES, HYDRAULIC, ELECTRONIC STABILITY CONTROL) HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 76,000.

Apr 20, 2021

POWER TRAIN,VEHICLE SPEED CONTROL,FUEL/PROPULSION SYSTEM

1 complaint

WHEN ACCELERATING THE TRUCK LOST ALL POWER AND ACCELERATION. ENGINE LIGHT IS ON. ENGINE WILL NOT INCREASE RPM WHEN ACCELERATOR IS PRESSED. TRUCK WILL SLOWLY DRIVE BUT IS UNSAFE TO BE ON THE ROAD AS IT SLOWLY ACCELERATES UP TO 20-30MPH MAX. VEHICLE WAS MERGING INTO TRAFFIC FROM PARKING LOT ACCESS.

Jan 21, 2021

EXTERIOR LIGHTING,STRUCTURE

1 complaint

PAINT PROBLEMS ON ALL FOUR DOORS FLAKING OFF .RECIEVING A NOTICE FOR MY CAMARY BUT NOT THE TACOMA, BOTH COLORS WERE LISTED.

Nov 07, 2020

ELECTRICAL SYSTEM,AIR BAGS

1 complaint

TOYOTA HAS KNOW THAT THE CLOCK SPRING HAS BEEN FAILING FOR YEARS. THEY ISSUED A RECALL FOR MODEL YEARS 2005-2009. TRUCKS IN THE MODEL YEARS 2010-2012 ARE ALSO AFFECTED. PROBLEMS - LOSS OF HORN, LOSS OF AIRBAG. OPTIONAL IF EQUIPPED - LOSS OF CRUISE CONTROL AND/OR LOSS OF RADIO CONTROLS. THIS IS A MAJOR SAFETY HAZARD! LOSS OR HORN AND LOSS OF AIR BAGS ARE A VERY, VERY DANGEROUS SITUATION!!! THE CLOCK SPRING FAILS RANDOMLY SO YOU MIGHT NOT BE AWARE UNTIL IT IS TOO LATE!!!

Oct 03, 2020

WHEELS,ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES

1 complaint

RIGHT FRONT WHEEL SUDDENLY LOCKS FOR SEVERAL SECONDS PUTTING A DRAG ON THAT WHEEL, SLOWING THAT WHEEL DOWN. HAPPENS ON SHARP TURNS ONLY SO FAR, MOSTLY GOING DOWN HILL, ALL AT REASONABLE, SAFE SPEEDS FOR THE CURVE. DRIVER IS NOT USING THE BREAKS AT THE TIMES THIS HAS HAPPENED, AND RELEASES THE GAS AND HOLDS TIGHT TO THE STEERING WHEEL. NO DASH LIGHTS APPEAR. IT IS INCREASING IN FREQUENCY AND STARTING TO SCARE US ON OUR DEEP CLIFF CURVE ROADS. THIS HAS BEEN HAPPENING JUST ONCE IN AWHILE 5 YEARS, BUT IS NOW HAPPENING 2-5 TIMES EACH TIME WE DRIVE THE 15 MILE RIVER CANYON WITH TIGHT CURVES AND STEEP CLIFFS. WE ONLY KNOW WHEELS ANS BRAKE SYSTEM ARE INVOLVED, AND THE STABILITY OF THE VEHICLE.

Sep 14, 2020

SUSPENSION,UNKNOWN OR OTHER,ENGINE

1 complaint

I BROUGHT TRUCK TO TOYOTA DEALERSHIP AS PART OF RUSTED FRAME RECALL TO BE VERIFIED. THEY STATED TRUCK WAS NOT RUSTED ENOUGH UNDERNEATH FOR TOYOTA TO APPROVE RECALL. THAT WAS A COUPLE OF MONTHS AGO. I HAVE RECENTLY BROUGHT IT TO A FEW MECHANICS TO DO SOME WORK ON A/C AS THE A/C STOPPED WORKING AND THAT REFUSE TO WORK ON IT AS THE TRUCK IS SO RUSTED UNDERNEATH!! THEY SAID IT WOULD CRUMBLE. NOT EVEN WORTH IT.

Aug 18, 2020

VEHICLE SPEED CONTROL,UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM

1 complaint

'TAKATA RECALL' SECONDARY AIR INJECTION PUMP SECONDARY AIR SWITCHING VALVES LIMP MODE DON'T GO OVER 40 CRUDE CONTROLS DOESN'T WORK

Jun 17, 2019

STEERING,STRUCTURE

1 complaint

WHEEL VIBRATES AND SHUDDERS IN MOTION, STEERING WHEEL BECOMES STIFF, DIFFICULT TO TURN WHILE HIGHWAY DRIVING.(SEE ZH@ TOYOTA SUPPORT PROGRAM). PER BOBBY RAHAL, LEWISTOWN PA, UNIVERSAL SHAFT AFFECTED, CORROSION NOTED. CONTACTED TOYOTA, RECALLS ON SAME REPORTED ISSUES ONLY COVERED ON TACOMA'S FROM 2005-2011; THEY WILL NOT COVER THE RECALLED SHAFT ASSEMBLY,UNIVERSAL JOINT AND HANGER FOR 2012 AS IT HAS NOT BEEN RECALLED AS OF YET. THEY WOULD RATHER HAVE LAWSUIT APPARENTLY FOR FAULTY SAFETY ISSUES

May 21, 2019

POWER TRAIN,AIR BAGS,ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

60,000 MILES. THREE YEARS AGO THE AIRBAG LIGHT CAME ON. WE BROUGHT IT AND PAID FOR DIAGNOSTICS BUT NO ANSWERS. NOW THE CHECK ENGINE LIGHT AND TRACK OFF ARE LIGHTING (NOT RELATED TO FIRST ISSUE) AND THE TRUCK IS IN SLOWDOWN MODE. WE REPLACED THE GAS-CAP BUT IT DIDN'T FIX THE ISSUE. DISAPPOINTED IN WHAT USED TO BE A QUALITY COMPANY.

May 09, 2019

POWER TRAIN,UNKNOWN OR OTHER

1 complaint

CHECK ENGINE LIGHT WITH TRAC OFF LIGHT COMES ON. NO POWER. AIR IDOL CONTROL VALVE STUCK OPEN.

Apr 12, 2019

STEERING,SUSPENSION

1 complaint

LOWER CONTROL ARM BALL JOINT GOES BAD ON BOTH SIDE CAUSE THE STEERING WHEEL TO VIBRATE.

Sep 05, 2018

EXTERIOR LIGHTING,SERVICE BRAKES

1 complaint

THE BRAKES ARE REAL TOUCHY AFTER IT RAINS OR REALLY HIGH HUMID DAYS. I FOUND MOISTURE IN THE LICENSE PLATE MAKER LIGHTS AND HOUSINGS WERE FULL OF WATER. AFTER CLEANING IT OUT THE BRAKES SEEM TO WORK NORMAL AGAIN. IT SEEMS THAT THE LIGHTS DO NOT HAVE TO OPERATE SWITCHED ON , FOR THIS SITUATION TO OCCUR.

Aug 14, 2018

TRACTION CONTROL SYSTEM,ENGINE

1 complaint

TL* THE CONTACT OWNS A 2012 TOYOTA TACOMA. WHILE DRIVING VARIOUS SPEEDS AND DEPRESSING THE ACCELERATOR PEDAL, THE VEHICLE FAILED TO ACCELERATE. ALSO, THE TRACTION CONTROL AND CHECK ENGINE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SECONDARY AIR INJECTION VALVE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 45,000.

Feb 14, 2018

VEHICLE SPEED CONTROL,UNKNOWN OR OTHER,ENGINE

1 complaint

ALMOST LOST CONTROL OF VEHICLE WHEN THE TRUCKS PERFORMANCE JUMPED INTO LIMP MODE "TRAC OFF" AS I WAS DRIVING. LOSS OF SPEED AND PERFORMANCE CAUSED ME TO BE A DRIVING HAZARD. 2 VENDORS TODAY FOUND THE CODES P2440 AND P2442, WHICH APPEAR TO HAVE TRIGGERED MY TRUCK INTO "TRAC OFF" AND "CHECK ENGINE" LIGHT ON. MODE CAUSES MY TRUCK TO ONLY DRIVE ABOUT 45 SIGNIFICANTLY IMPACTS PERFORMANCE AND DANGEROUS TO DRIVE. THIS IS A SAFETY HAZARD,I HAD NO WARNING THAT THE LOSS OF PERFORMANCE WAS GOING TO HAPPEN INITIALLY WHEN I WAS TRAVELING.THERE IS ANOTHER PROBLEM THAT APPEARS TO BE ON A LARGER SCALE.I HAVE BRIEFLY SCANNED THE INTERNET IN THE LAST HOUR AND SPOKE WITH VARIOUS VENDORS ABOUT THE PROBLEM & I HAVE CALLED MY DEALERSHIP & EVEN THE MAIN TOYOTA LINE AND EVERYONE IS AWARE OF THE ISSUE. THE CODES ARE P2440 & P2442. AFTER FINDING OUT THE CODES I LOOKED AT THE AIR INJECTION PUMP & I WAS ASTONISHED TO SEE THAT THE PUMP WAS COMPLETELY FULL OF WHAT, LIKE SOMEONE LITERALLY TOOK A WATERHOSE & FILLED IT UP. LOGICALLY, THIS IS WHY THE AIR INJECTION SWITCHING VALVES 1 AND 2 ARE BOTH STUCK OPEN ONE CODE FOR EACH OF THE VALVES. THE NEXT THING THAT IS UNUSUAL IS THAT THERE ARE AN INCREDIBLE AMOUNT OF PEOPLE HAVING THIS SAME PROBLEM BUT NO RECALL..THEN I FOUND THE TUNDRA RECALL FOR THE EXACT SAME PUMP ISSUE! IT IS PECULIAR, THAT A DIFFERENT MODEL TRUCK WITH THE SAME PUMP HAS THIS PROBLEM & NO RECALL OR REMEDY. FACT-TUNDRA IS A MORE EXPENSIVE TRUCK THAN TACOMA, IS TOYOTA FIXING PUBLIC RELATION ISSUES FOR THOSE MORE WELL OFF BECAUSE THEY KNOW HOW TO COMPLAIN TO THE RIGHT FOLKS OR CAUSE A BIG STIR AND THEY WILL HOLD OFF ON PULLING THE TRIGGER ON A "WARRANTY FIX OR RECALL" ON THE WORKING MANS TACOMA? THIS IS JUST AN OPINION BUT MY INTUITION TELLS ME THIS IS INTENTIONAL. THE FIX IS APPROX $2000 I AM STUCK DRIVING 45 MPH TILL THEN WITH SHADY STEERING & PERFORMANCE. #ACCOUNTABILITY #ME TOO

Dec 22, 2017

ELECTRONIC STABILITY CONTROL (ESC),ENGINE

1 complaint

AT START UP "CHECK ENGINE" AND "TRAC OFF" LIGHTS WERE ON. TRUCK HAD NO ACCELERATION AND TRANSMISSION WOULD NOT SHIFT. I TOOK THE CAR TO THE DEALERSHIP AND DIAGNOSTIC CODES P2440 AND P2442 WERE DETECTED. DEALER HAD TO REPLACE THE AIR INJECTION SYSTEM BANK 1 AND BANK 2. DURING RESEARCH, I DISCOVERED NUMEROUS OTHER OWNERS OF 2012 TACOMA'S COMPLAING ABOUT THE SAME ISSUE. SOME EVEN LOST POWER WHILE DRIVING. ALSO, THE TUNDRA APPARENTLY HAD A SIMILAR ISSUE BEING REPORTED

Aug 05, 2017

STEERING,ELECTRICAL SYSTEM

1 complaint

HORN QUIT WORKING, ONLY WORKS WHEN THE WHEEL IS TURNED TO THE LEFT, FUSES ARE GOOD AND SO ARE THE RELAYS.

Jul 29, 2017

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,SERVICE BRAKES

1 complaint

DRIVING AT HIGH WAY SPEED; THE ABS LIGHT, PARKING BRAKE LIGHT, TRACTION LIGHT, LOST POWER TO WINDOWS, A/C, RADIO, POWER STEERING, ENGINE WAS RUNNING ROUGH, THEN THE CHECK ENGINE LIGHT CAME ON. COULD BE A SAFETY ISSUE OF CONTROL OF VEHICLE FOR DRIVERS NOT PAYING ATTENTION. TOYOTA DEALER SAID THE ROOT CAUSE WAS A BAD CELL IN BATTERY THAT CAUSED THE IGN#2 FUSE TO BE BLOWN. THESE BATTERIES HAVE KNOWN ISSUES TO BE BAD FROM THE FACTORY. REPORTED EARLIER ABOUT 30000 MILES THE FACTORY BATTERY WOULD NOT START VEHICLE AND DEALER SAID THEY REPLACED BECAUSE OF A BAD CELL. I OWN A 2008 TOYOTA TACOMA ALSO , SAME MODEL AND MAKE AS BEING REPORTED AND THAT BATTERY HAS BEEN REPLACED 2 TIMES FOR SAME REASON.

Jul 10, 2017

VEHICLE SPEED CONTROL,ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

I HAVE CHECK ENGINE LIGHT ON AND THE TRAC OFF LIGHT ON. THIS COMMON PROBLEM WIYHE TUNDRA MODEL. ALOT OF TACOMA OWNER HAVE SAME PROBLEM BUT TACOMA DOE NOT HAVE EXDENDED WARRANTY LIKE THA TUNDRA. MY TRUCK ONLY HAVE 59K MILES IT'S ONLY 5YEARS AND 3 MONTHS OLD THEY SAID WON'T COVER THE PROBLEM. PROBLEM 1 SECONNDARY INJECTION SYSTEM VALVE I HAVE TO CODE P2440 P2442.

Jun 15, 2017

UNKNOWN OR OTHER,ELECTRONIC STABILITY CONTROL (ESC),ENGINE

1 complaint

VEHICLE WAS IN MOTION ON RAINY, WET HIGHWAY WHEN CHECK ENGINE LIGHT WENT ON AND TRACTION CONTROL WAS SHUT OFF. THE SECONDARY AIR INJECTION SWITCHING VALVE IS APPARENTLY STUCK CLOSED, WHICH FOR SOME REASON SHUTS OFF THE TRACTION CONTROL. IT IS MY UNDERSTANDING FROM SPEAKING WITH OTHER TACOMA AND TUNDRA OWNERS THAT HAD THE VALVES GOTTEN STUCK OPEN, THE VEHICLE GOES INTO "LIMP MODE" WHICH AUTOMATICALLY DECREASES SPEED TO 20MPH. OBVIOUSLY, EITHER OF THESE OCCURRENCES ARE PARTICULARLY UNSAFE IN RAINY AND WET CONDITIONS, AND THE DECREASE IN SPEED IS UNSAFE DURING ANY HIGHWAY TRAVELING. THIS IS APPARENTLY A BIG ENOUGH ISSUE ON THE TUNDRA MODELS FOR TOYOTA TO EXTEND THE WARRANTY TO 150,000MI, YET THEY HAVE DONE NOTHING FOR THE TACOMAS WHICH HAVE AN IDENTICAL SYSTEM AND PARTS.

Jun 01, 2017

POWER TRAIN,ELECTRONIC STABILITY CONTROL (ESC),ENGINE

1 complaint

2012 TACOMA WITH 37,00 MILES: WHILE LEAVING A PARKING LOT AND TRYING TO ACCELERATE ON TO A BUSY HIGHWAY, (60MPH SPEEDS), TRUCK WOULD NOT ACCELERATE AND "CHECK ENGINE" AND "TRAC OFF" LIGHTS ILLUMINATED. VEHICLE WENT INTO "LIMP MODE" AND WOULD NOT GO FASTER THAN 35 MPH. I HAD TO QUICKLY PULL OFF THE ROAD AS TO NOT CAUSE AN ACCIDENT. IF THIS HAD THIS OCCURRED WHILE TRAVELING AT NORMAL HIGHWAY SPEED (60 MPH+), WOULD DEFINITELY BE IN A WRECK DUE TO THE SUDDEN DOWNSHIFT AND DECELERATION. I TOOK VEHICLE TO LOCAL AUTO PARTS STORE AND RECEIVED THE CODE P2442: SECONDARY AIR INJECTION SYSTEM SWITCHING VALVE STUCK OPEN BANK 2. FROM RESEARCHING, THIS IS A KNOWN PROBLEM WITH 2012 TACOMAS, AND HAD PREVIOUSLY BEEN AN ISSUE WITH OLDER TUNDRAS, WHICH TOYOTA ISSUED A TSB FOR. TOYOTA REFUSES TO REPAIR THIS UNDER WARRANTY (EITHER POWERTRAIN OR FEDERAL EMISSIONS) EVEN THOUGH THE FAILED PART IS DIRECTLY TIED TO THE EMISSIONS SYSTEM! THE SYSTEM IS USED TO PUMP ADDITIONAL AIR INTO THE EXHAUST MANIFOLD UPON STARTUP TO DILUTE THE OVER-RICH CONDITIONS THAT LEAD TO INCREASED POLLUTION. (HOW IS THAT NOT AN EMISSIONS RELATED PART?) THE FAILURE OR WARPING OF THE ONE-WAY CHECK VALVE CAUSES HOT EXHAUST GASES TO BACKFLOW INTO THE SOLENOID, AND MELTING THE GASKETS. THIS ENDS UP BLOCKING THE SEALING PLATE AND CAUSING IT TO REMAIN IN THE OPEN POSITION. THE DANGER IS THAT THE HOT EXHAUST IS THEN FED INTO A PLASTIC AIR PUMP CAUSING IT TO POTENTIALLY MELT OR CATCH FIRE! THE FACT THAT THIS FORCES THE VEHICLE INTO "LIMP MODE" IS ALSO A HUGE SAFETY CONCERN AS IT WILL NOT ALLOW THE VEHICLE TO TRAVEL ABOVE 35 MPH AND COULD LEAD TO SERIOUS ACCIDENTS IF TRAVELING AT HIGH SPEED ON THE INTERSTATE OR HIGHWAY DUE TO THE UNEXPECTED, SUDDEN DECELERATION. FAILED ASSEMBLY IS TOYOTA PART NUMBER : 25710-31020. THIS PART NUMBER HAS BEEN SUPERSEDED BY P/N: 25710-31022 AND TOYOTA CHARGES BETWEEN $1500-$3200 TO REPLACE. *TR

Dec 23, 2016

POWER TRAIN,UNKNOWN OR OTHER,ENGINE

1 complaint

SECONDARY AIR INJECTION SWITCHING VALVE FAILURE STUCK IN OPEN POSITION CAUSING LIMP MODE IN THE TRUCK. TRUCK IS NOT ABLE TO GET TO SPEED ABOVE 40 MPH. THIS HAPPENED AS I WAS PULLING OUT OF MY NEIGHBORHOOD ONTO A STATE ROUTE WITH SPEED LIMIT OF 55 MPH AND CARS GOING WAY FASTER THAN THAT. THIS COULD POSE A DANGER IF SITUATIONS WHERE SPEED IT REQUIRED TO GET OUT OF THE WAY OF ANOTHER CAR. TRUCK ONLY HAS 57K MILES ON IT. THIS IS A SUPPLEMENTAL EMISSIONS SYSTEM AND SHOULD NOT CAUSE THE TRUCK TO BE USELESS IF FAIL.

Sep 07, 2016

VEHICLE SPEED CONTROL,UNKNOWN OR OTHER

1 complaint

I STARTED MY TACOMA, THE CHECK ENGINE LIGHT AND TRK OFF LIGHTS WERE ON AND AFTER TAKING THEM TO THE DEALER LEARNED THAT THE VECHILE WAS IN LIMP MODE. THE TRUCK WILL NOT EASILY ACCELERATE BEYOND 30MPH. THIS IS CAUSED BY ERROR CODE P2442 AND P2440, FROM A KNOWN FAULTY PART THAT TOYOTA REFUSES TO REPLACE.

Jun 30, 2016

POWER TRAIN,UNKNOWN OR OTHER,ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

AS I'VE READ FROM NUMEROUS OTHER 2012 TACOMA OWNERS ON TACOMAWORLD.COM, MY SECONDARY AIR INJECTION SWITCHING VALVE HAS FAILED AT 65K MILES. THIS SEEMS TO BE A RECURRING ISSUE WITH ALL 2012 SIMILAR TACOMA MODELS AND SHOULD ABSOLUTELY BE RECALLED AND REPLACED FOR FREE! UNTIL FIXED, MY TRUCK IS UNDRIVABLE, MEANING THE CEL LIGHT IS ON AND THE TRUCK WON'T GO FASTER THAN 30 MPH.

Jun 07, 2016

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM

1 complaint

THE SECONDARY AIR INJECTION SYSTEMS SEEMS TO FAIL QUITE FREQUENTLY ON THESE 2012 TACOMAS WITH LITTLE TO NO HELP FROM TOYOTA TO TAKE CARE OF THIS ISSUE AS A RECALL. THESE ARE KNOWN TO FAIL RIGHT AFTER YOUR OUT OF WARRANTY AND TO CHARGE IT'S LOYAL CUSTOMERS OVER $1000 FOR A PART THAT SHOULD NOT FAIL OR A PART THAT SHOULD BE COVERED IS ABSURD. I HAVE BEEN A LOYAL TOYOTA CUSTOMER MY WHOLE LIFE BUT THE ISSUES OF THE TACOMA ARE MAKING ME RETHINK MY DECISIONS AS AN AUTOMOTIVE CONSUMER

May 31, 2016

UNKNOWN OR OTHER,ELECTRONIC STABILITY CONTROL (ESC)

1 complaint

CHECK ENGINE LIGHT CAME ON AND VEHICLE WAS NOT GOING PAST 2K RPM AND OVER 20MPH. CONNECTED TO AN ONBOARD DIAGNOSTIC READER WHICH GAVE ME CODES P2440 AND P2442- SECONDARY AIR INJECTION VALVE STUCK OPEN BANK 1 & 2. VEHICLE HAS LESS THAN 50,000 MILES AND ONLY 4 YEARS OLD AND TOYOTA DOES NOT COVER FAULTY EQUIPMENT UNDER ANY WARRANTY (POWERTRAIN OR FEDERAL EMISSIONS) ALTHOUGH THEY HAVE ISSUED CANADA TSB 3861 ACKNOWLEDGING THE DEFICIENCY, BUT LEAVING THE OWNER TO PAY $645.00 FOR THE REPLACEMENT PART FROM TOYOTA DEALER. THIS IS UNSATISFACTORY- THEY MUST BE HELD ACCOUNTABLE FOR A VEHICLE STILL WITHIN POWERTRAIN (60,000MI) OR FEDERAL EMISSION (80,000MI) WARRANTY.

May 04, 2016

ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

1 complaint

FUEL SYSTEM CAN BE HEARD HOURS AFTER THE TRUCK IS PARKED, FEW TIMES A WEEK AND SOMETIMES DAILY .AND RUNS 2 TO 15 MINUTES. CONTACTED DEALER AND SAYS IT NORMAL FOR FUEL EVAP TO DO A SYSTEM CHECK. ONGOING STARTED BEFORE 3000 MILES

Nov 06, 2015

ELECTRICAL SYSTEM,AIR BAGS,STRUCTURE

1 complaint

DRIVING MY TOYOTA TACOMA, I WAS APPROACHING A STEEP DECLINE. I TAPPED ON THE BRAKES AND CONTINUED DRIVING AT APPROXIMATELY 27 MPH WHEN I DOWN SHIFTED TO ACCOMMODATE FOR THE SNOWY ROAD. AS I WAS DOWN SHIFTING THE TRUCK LOST CONTROL AND SLID SIDEWAYS CAUSING THE FRONT PASSENGER SIDE TO HIT A SNOW BANK. ONCE THE TRUCK STRUCK THE SNOW BANK IT FLIPPED OVER ON ITS DRIVER SIDE. THE SIDE AIR BAGS ON BOTH SIDES CAME OUT BUT DID NOT INFLATE. THE DRIVER SIDE BAGS WERE TORN. I FOUND EVIDENCE OF THIS WITH SHREDDED PIECES OF THE AIR BAG FOUND IN THE VEHICLE. ADDITIONALLY THE DRIVER SIDE FRONT AIR BAGS NEVER DEPLOYED..UPDATED 03-02/15 *BF.....UPDATED 03-11-15 *BF UPDATED 9/22/2017*CN

Feb 18, 2015

Crash: 1

TIRES

1 complaint

TL* THE CONTACT OWNS A 2012 TOYOTA TACOMA EQUIPPED WITH BF GOODRICH RUGGED TRAIL TIRES, LINE SIZE P265/70 R16. THE CONTACT MENTIONED THAT WHILE HAVING REGULAR MAINTENANCE PERFORMED, HE NOTICED THAT ALL FOUR TIRES HAD CRACKED SIDEWALLS. THE TECHNICIAN ADVISED THAT ALL FOUR TIRES NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE TIRES WERE REPLACED. THE DOT AND THE VIN WAS NOT AVAILABLE. THE TIRE FAILURE MILEAGE WAS 17,245. UPDATED 06/10/14*LJ UPDATED 8/23/2017*CN

Apr 29, 2014

SUSPENSION,POWER TRAIN,STRUCTURE

1 complaint

I WAS APPROACHING A STOPLIGHT AT A DOWNWARD ANGLE AND WHILE APPLYING THE BRAKE THE VEHICLE BEGAN TO SHAKE VIOLENTLY. I WAS GOING APPROX. 15PMH WHEN IT STARTED AND IT DIDN'T STOP SHAKING UNTIL I GOT DOWN TO ABOUT 5 MILES PER HOUR. I TOOK IT TO THE DEALERSHIP THAT DAY AND EXPLAINED THE PROBLEM TO THEM. THEY GOT THE VEHICLE TO REPRODUCE THE VIBRATIONS AND I HAVE PAPERWORK STATING THIS. IT HAS BEEN A FULL YEAR LATER AND THEY HAVEN'T REPAIRED IT YET. THEY CONTINUALLY TELL ME PARTS ARE BEING DESIGNED. JUST WAIT. THAT'S ALL THEY KEEP SAYING. I FOUND OUT THAT THEY MADE A FIX FOR THE V6 MODEL WITHIN 7 MONTHS, BUT THEY DIDN'T HAVE ENOUGH COMPLAINTS AGAINST THE 4 CYLINDER MODEL TO WARRANT REDESIGNING PARTS. I WAS TOLD THIS BY THE SERVICE TECH AT THE DEALERSHIP. *TR

Apr 22, 2014

EXTERIOR LIGHTING

1 complaint

TL* THE CONTACT OWNS A 2012 TOYOTA TACOMA. THE CONTACT STATED THAT THE DRIVER'S SIDE HEADLIGHT FAILED TO ILLUMINATE PROPERLY AND THE LIGHT WAS DISTORTED. THE VEHICLE WAS TAKEN THE DEALER FOR DIAGNOSIS. THE DEALER STATED THAT THERE WAS NO DEFECT WITH THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 10.

Apr 16, 2014

EQUIPMENT,ENGINE

1 complaint

TL* THE CONTACT OWNS A 2012 TACOMA. THE CONTACT STATED THAT HE ADDED OIL TO THE VEHICLE AS DIRECTED BY THE OWNER'S MANUAL BUT THE ENGINE OVERFLOWED. THE CONTACT STATED THAT THE ENGINE WAS OVERFILLED BY 19.2 OZ. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT THAT THE INFORMATION LISTED IN THE OWNER'S MANUAL WAS CORRECT. UPDATED 6/17/14*CN

Apr 11, 2014

VEHICLE SPEED CONTROL,SERVICE BRAKES,FUEL/PROPULSION SYSTEM

1 complaint

MY TACOMA TENDS TO SURGE FORWARD WHEN IT IS STOPPED. I DO NOT THINK IT HAS ANYTHING TO DO WITH THE AIR CONDITIONER BEING ON.I HAD THE A/C OFF THE FIRST TIME. IF SOMEONE ISN'T ON THE BRAKE FIRMLY THEY MAY TAP THE VEHICLE IN FRONT OF THEM. *TR

Oct 26, 2013

FUEL SYSTEM, GASOLINE

1 complaint

FUEL PUMP CAN BE HEARD OPERATING AT TIMES, USUALLY AFTER SEVERAL HOURS OF BEING PARKED. SLIGHT GRINDING NOISE WAS ALSO HEARD ASSOCIATED WITH THE FUEL PUMP. SERVICE DEPARTMENT AT DEALER, STATED COULD NOT DUPLICATE AND CONSIDERED THE MATTER CLOSED. *TR

Jul 23, 2013

STEERING,SUSPENSION,WHEELS

1 complaint

STEERING WHEEL SHAKES AT HIGHWAY SPEED, TOYOTA ESCONDIDO HAS BEEN ABLE TO DUPLICATE'S PROBLEM. WHEELS HAVE BEEN ROTATED AND BALANCED AND PROBLEM STILL PERSIST, VEHICLE IS NOW AT 9100 MILES AND I PLAN HAVING DEALER LOOK AT ISSUE AGAIN , BUT I'M CONCERNED THIS COULD LEAD TO A MORE SERIOUS ISSUE THAT COULD AFFECT THE SAFETY OF THE VEHICLE.I HAVE RESEARCHED FORUMS AND FOUND NUMEROUS COMPLAINTS REGARDING THIS ISSUE THAT SEEMS TO PLAGUE THE TACOMA LINE. *TR

May 20, 2013

SEATS

1 complaint

2012 TOYOTA TACOMA. CONSUMER WRITES IN REGARDS TO LOOSE FRONT SEAT ON THE PASSENGER SIDE *TGW THE DEALER INFORMED THE CONSUMER IT WAS NORMAL, FOR HIS MODEL VEHICLE.

Sep 20, 2012

2012 TOYOTA Tacoma Problems & Complaints

Complaints by Component

Frequently Asked Questions

How many problems does the 2012 TOYOTA Tacoma have?

What are the most common problems with 2012 TOYOTA Tacoma?

Where does this 2012 TOYOTA Tacoma problem data come from?

Other Years - TOYOTA Tacoma

Other TOYOTA Models

Similar Brands