1996 FORD Aerostar Recalls

VIN Decoder

Premium Report

Recalls Found

Radar Detector GPS Tracker OBD2 Scanner Car Refrigerator Jump Starter Dash Cam

As an Amazon Associate, ForCar.org earns from qualifying purchases.

All Recalls

CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.

NHTSA 06E022000

Report Date

13/03/2006

Component

SERVICE BRAKES, HYDRAULIC

Manufacturer

BRAKE PARTS, INC.

Consequence: LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.

Remedy / Corrective Action

AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.

VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES WERE PRODUCED WITH A HIGHER THAN SPECIFIED ELECTRICAL LOAD THROUGH THE ACCESSORY POWER FEED CIRCUIT. THE POTENTIAL FOR CONTACT BETWEEN THE B2 (BATTERY), A2 (ACCESSORY), AND P1 (PROOF) CIRCUITS CAN OCCUR, CREATING A SHORT CIRCUIT, ALLOWING CURRENT TO FLOW THROUGH THE GROUND WIRE.

NHTSA 99V029000

Report Date

09/02/1999

Component

ELECTRICAL SYSTEM:IGNITION:SWITCH

Manufacturer

FORD MOTOR COMPANY

Consequence: THIS CAN CAUSE OVER HEATING AND THE POTENTIAL FOR A VEHICLE FIRE.

Remedy / Corrective Action

DEALERS WILL INSTALL A JUMPER HARNESS WITH A RELAY WHICH WILL RE-ROUTE AND ACTIVATE ALL A2 ACCESSORIES THROUGH THE RELAY.

WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."

NHTSA 96V070000

Report Date

22/04/1996

Component

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Manufacturer

FORD MOTOR COMPANY

Consequence: THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1,000 POUND TRANSVERSE LOAD.

Remedy / Corrective Action

DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER DOOR LATCH.

VEHICLE DESCRIPTION: ALL WHEEL DRIVE PASSENGER MINIVANS. THESE VEHICLES CAN DEVELOP POWERTRAIN BENDING RESONANCE OR TRANSFER CASE OUTPUT SHAFT BUSHING DISPLACEMENT. THE POWERTRAIN BENDING RESONANCE OR THE OUTPUT SHAFT BUSHING DISPLACEMENT CAN RESULT IN STRUCTURAL FAILURE OF THE TRANSMISSION AND/OR TRANSFER CASE. FLUID EXPLUSION, DRIVESHAFT SEPARATION OR LOSS OF VEHICLE DRIVE CAN RESULT.

NHTSA 97V204000

Report Date

13/11/1997

Component

POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

Manufacturer

FORD MOTOR COMPANY

Consequence: THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, AND, IF THE EXPELLED FLUID CONTACTS THE EXHAUST SYSTEM, A VEHICLE FIRE COULD OCCUR.

Remedy / Corrective Action

DEALERS WILL INSTALL A NEW TRANSFER CASE REAR OUTPUT SHAFT BUSHING AND AN ALUMINUM DRIVESHAFT WILL BE INSTALLED.

THE CERTIFICATION LABELS ON THE INVOLVED VEHICLES HAS INCORRECT REAR TIRE INFLATION PRESSURE DESIGNATIONS. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

NHTSA 96V161000

Report Date

29/08/1996

Component

EQUIPMENT:OTHER:LABELS

Manufacturer

FORD MOTOR COMPANY

Consequence: INCORRECT INFLATION PRESSURES COULD CAUSE PREMATURE WEAR OF THE REAR TIRES. .

Remedy / Corrective Action

OWNERS WILL BE PROVIDED WITH CORRECT CERTIFICATION LABELS AND INSTRUCTIONS FOR INSTALLING THESE LABELS. DEALERS CAN INSTALL THIS LABEL IF THE OWNER SO DESIRES.

EQUIPMENT DESCRIPTION: AFTERMARKET BRAKE ROTORS FOR USE ON CERTAIN FORD AND MAZDA TRUCKS. CRACKED CASTINGS CAUSED CRACKS TO APPEAR ON THE OUTER DIAMETER OF THE ROTOR HAT OR AROUND THE STUD HOLE.

NHTSA 98E010000

Report Date

08/04/1998

Component

SERVICE BRAKES, AIR:DISC:ROTOR

Manufacturer

AIMCO PRODUCTS INC.

Consequence: LOSS OF BRAKING CAN RESULT.

Remedy / Corrective Action

AIMCO WILL REIMBURSE CONSUMERS/INSTALLERS FOR THE COST OF REPLACEMENT ROTORS AND INSTALLATION. CONSUMERS ARE REQUESTED TO RETURN TO THE LOCATION WHERE THE ROTORS WERE ORIGINALLY PURCHASED/INSTALLED FOR REPLACEMENT.

4.4/5.0

29 reviews

Where to Find VIN for Recall Check

To check for recalls on your 1996 FORD Aerostar, you'll need the VIN number. Find your VIN in one of these 4 common locations.

Where to Find VIN Number on 1996 FORD Aerostar for Recall Lookup - Dashboard, Door Jamb, Engine Bay, Documents

Understanding VIN Structure for Recall Verification

Each character in your 1996 FORD Aerostar 17-digit VIN helps identify specific recalls affecting your vehicle. Learn how the VIN structure works for accurate recall lookup.

1996 FORD Aerostar VIN Structure for Recall Verification - WMI, VDS, Check Digit, Model Year, Plant Code

How to Check 1996 FORD Aerostar Recalls in 3 Steps

Locate Your VIN

Find the 17-character VIN on your 1996 FORD Aerostar dashboard (visible through windshield), door jamb, engine bay, or vehicle documents.

Enter VIN in Checker

Input your VIN into our free recall checker tool above to search NHTSA database for safety recalls, TSBs, and service campaigns specific to your vehicle.

Review & Schedule Repair

Check the recall details including affected components, consequences, and remedy. Contact your FORD dealer to schedule free recall repair appointment.

Frequently Asked Questions

How many recalls does the 1996 FORD Aerostar have?

The 1996 FORD Aerostar currently has 6 recalls according to NHTSA records. All recall information is sourced directly from the National Highway Traffic Safety Administration database.

Are 1996 FORD Aerostar recalls free to fix?

Yes! All safety recalls for 1996 FORD Aerostar vehicles must be repaired free of charge by authorized dealers, regardless of vehicle age or mileage. Contact your local FORD dealer to schedule a recall repair.

How do I check if my 1996 FORD Aerostar has open recalls?

You can check for open recalls by entering your VIN (Vehicle Identification Number) in our VIN decoder tool. The 17-character VIN can be found on your vehicle registration, insurance card, or on the driver's side dashboard visible through the windshield.

Where can I find my 1996 FORD Aerostar VIN number?

Your 1996 FORD Aerostar VIN is located in 4 places: (1) Dashboard near windshield on driver's side, (2) Driver's door jamb sticker, (3) Engine bay, (4) Vehicle registration and insurance documents.

What should I do if my 1996 FORD Aerostar has a recall?

Contact your nearest FORD dealership immediately to schedule a free recall repair. Bring your vehicle registration or VIN number. All safety recalls must be fixed free of charge by the manufacturer, regardless of vehicle age or mileage.

Are NHTSA recalls mandatory to fix on 1996 FORD Aerostar?

While not legally required for vehicle owners to fix recalls, it's strongly recommended for safety. However, dealerships and manufacturers must offer free repairs for all official NHTSA recalls on 1996 FORD Aerostar vehicles.