2017 FORD Fusion Problems & Complaints
Real owner complaints and problems reported to the National Highway Traffic Safety Administration (NHTSA). View common issues by component.
VIN Decoder
1059
Complaints Reported
As an Amazon Associate, ForCar.org earns from qualifying purchases.
Complaints by Component
ENGINE
264 complaints
Coolant intrusion into the engine causing my car to missfire going down the road. Car is sitting in my yard unfit to be driven. Dealership claims it had previously been remedied. The car has only been inspected by my mechanic. No prior warnings before the misfire occurred
Jan 30, 2026
Engine failed. Lost all compression. Evidently this is a known problem with this engine where the head, head gasket and block fail between cylinders.
Jan 26, 2026
2017 fusion 1.5 ecoboost.(purchased at 128k) 148k miles- 1 time white smoke at start up no check engine light. All of a sudden while driving started to drive rough. Towed too mechanic, determined cylinder #2 has coolant intrusion. Conducted the TSB. For this defect. All symptoms confirmed for the coolant intrusion. Got Quoted $10k for engine replacement. Vehicle has been parked in driveway since 10/24/25 too expensive too repair for a defective problem from ford.
Jan 22, 2026
My Ford Fusion has the 1.5L ecoboost engine. This engine has engineering issues that are known to Ford. My vehicle started producing white smoke from the exhaust and sluggish performance. At approximately 105,000 miles my vehicle went into limp mode due to a cracked head gasket. This was due to coolant intruding into the cylinders. Ford did a short block engine replacement and reprogrammed the PCM to try to fix the issue. At approximately 220,000 miles the vehicle started producing the same symptoms described earlier and the vehicle now requires a complete engine replacement. Ford refuses to fix this for me, even though it is well documented that this engine has engineering issues. These engines should last longer than 105,000 miles.
Jan 15, 2026
Vehicle is experiencing coolant intrusion from a crack in the engine block 3rd cylinder which is a known issue by Ford for my particular vehicle year (2017). Ford has issued a TSB/Recall for model years 2017-2019, I believe this issue should qualify for manufacturer recall as this is known issue.
Dec 25, 2025
+ 259 more complaints for this component
POWER TRAIN
220 complaints
Wrench light came on my car while driving 30mph, then the engine light. Had it diagnosed & I am told my car that went to the shop with code p0741 needs a NEW transmission!! 54, 618 miles only. Fix is $6800.00. I was told not to drive the car as it could seize up.
Dec 18, 2025
The Transmission in the Ford Fusion 1.5 L engine just stop working. The car will go and then the transmission would just stop working. The you could turn the car off and it would drive again and stop working again. It took me turning the car off about 12 times to get it home. This was just a test drive after my daughter had it towed home after being stranded. This is a safety issue for not only young girls being stranded, but everybody being stranded without any warning! Ford knows there is an issue, hopefully the Ford Executives are warning their love ones not to buy a Ford Fusion Model that has this issue.
Oct 17, 2025
In 5/2025 I had the transmission light come on my dashboard, then it went away. 2 days later I could not shift my car into drive only reverse or neutral. When I popped the hood the Shifter cable was detached and the bushing was in pieces. I purchased the ford OEM parts and replaced it. Today 10/8/25 The light appaired on my dash again. When I got home I popped the hood and the bushing was in pieces. Luckily I had purchased 2 replacement parts in May. I replaced it and it seems to be working. But I should not have to replace them this often. Today 10/8/25 I am purchasing 2 more just in case. But can we get this fixed with something more sturdy.
Oct 08, 2025
BUSHING FOR SHIFTER BUSTED, PERVIOUS RECALLS ON 2013-2016 MODELS, NUMEROUS REPORTS KNOWN FOR THIS HAPPENING ON 2017-2019 MODELS AS WELL. CURRENTLY HAVING VEHICLE BUSHING REPAIR AFTER CAR BEING IN THE SHOP FOR OVER A WEEK AFTER HAVING FRONT LINE BRAKE HOSES REPLACED AS WELL.
Oct 07, 2025
While changing my car from park to drive my vehicle got Stuck in reverse and wouldn’t come out even after turning car off which usually force vehicle to go into park. This was most likely due to the shifting cable bushing no longer being there and possibly disintegrating. Due to left over residue in the general area. I saw this was a recall for fords from I believe 2013/2014 up 2016 for the same issue. I go online and their are a couple of pages claiming this has happened to them as week or to check it to make sure it’s still on.
Sep 21, 2025
+ 215 more complaints for this component
ENGINE AND ENGINE COOLING
98 complaints
The contact owns a 2017 Ford Fusion. The contact stated that while driving at an undisclosed speed, the temperature gauge indicated that the engine was overheating, prompting the contact to discontinue driving the vehicle. The check engine warning light was illuminated. The vehicle was taken to the dealer, who determined there was coolant intrusion into several cylinders, resulting in damage to the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to the Customer Satisfaction Program: 21N12. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 85,000.
Nov 12, 2025
The contact owns a 2017 Ford Fusion. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed that there was coolant intrusion into the cylinders. The dealer determined that the engine needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure, but no assistance was provided. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 61,000.
Aug 15, 2025
The contact owns a 2017 Ford Fusion. The contact stated that upon starting the vehicle, the engine experienced a rough start and idling, and the check engine warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed, and the contact was advised that the engine was faulty due to coolant intrusion. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 90,000.
Aug 07, 2025
The contact owns a 2017 Ford Fusion. The contact stated that while driving 40 MPH, there was an abnormal slushing sound coming from the engine compartment. Additionally, the vehicle shuddered violently, the engine overheated, and the vehicle stalled. The check engine and powertrain warning lights were illuminated. The vehicle was able to restart. The vehicle was taken to the dealer, where it was diagnosed with engine failure. The dealer determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 136,000.
Jul 31, 2025
The contact owns a 2017 Ford Fusion. The contact stated that there was white smoke coming out of the exhaust pipe on cold starts and while driving at various speeds. The check engine warning light and the low coolant warning light were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with coolant intrusion into the cylinders through a cracked engine block. The mechanic determined that the engine needed to be replaced. The mechanic informed the contact that it was known failure and referred the contact to a dealer for assistance. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA for assistance. The failure mileage was approximately 196,000.
Jul 30, 2025
+ 93 more complaints for this component
ELECTRICAL SYSTEM
53 complaints
My backup camera on my 2017 ford fusion failed causing a blue screen on my infotainment screen camera is faulty and is a common issue among other vin numbers using the same part
Jan 30, 2026
In our 2017 Ford Fusion, the back up camera sometimes says "unavailable at this time" (or something close to that) when put in reverse. It is available for inspection upon request. Safety is put at risk for multiple parties - the driver/owner, individual(s)/property behind the vehicle, insurance companies, and potentially others as the total view between mirrors and the backup camera is compromised. The vehicle has not been taken to a dealership as it is out of warranty. I see where Ford has a recall on some of these, so I checked both NHTSA and Ford websites, and it says this vehicle is ineligible for repair. However, we are experiencing this problem from time to time, most recently 2 days ago when our [XXX] old was driving it. He called to let us know what the camera was doing. I believe having a safety device glitching is unnacceptable, and I would like to see Ford resolve this issue for not just my car but all of them having a KNOWN issue! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Dec 26, 2025
The 12v battery on my 2017 Fusion Energi titanium has failed every 6-10 months since buying the car new. Each failure is at best, inconvenient and expensive, however on multiple occasion it resulted a dangerous situation that compounded, knocking out fuses for components which manage power steering and other components. It was extremely difficult to pull over safely with my two young children and we were left stranded until we had a replacement battery delivered on the freeway. Ford knows this is a problem and says that it’s because the car is designed without a alternator and then changed the warranty coverage on the batteries from 3 to 2 years because of how much money they’ve been losing on replacements with warranty tolling.
Dec 11, 2024
I purchased this vehicle in late 2017 and immediately experienced an electrical issue that de-charged the battery. It was less than two weeks after my initial purchase. Since then, I have been stranded several times, inconvenienced, and frustrated by the level of service I received at Liccardi Ford in Watchung NJ. I have replaced this battery 4 other times since the initial replacement. This is clearly an electrical defect that NO ONE at Ford wishes to acknowledge. Instead of pouring more money into this vehicle or filing a legal claim, I contact the FORD CUSTOMER RELATIONS LINE (Spoke with someone name William) who failed to be considerate of my particular situation. This has been happening to me as a Ford customer for 7 years!!!!. In that time frame, I replaced the battery 5 times. That is not normal. I would to report that this is a defect and a recallable issues. Ford should have accepted this issue as a recallable defect years ago. Please see this and many other reported electrical issues with the Ford Fusion: [XXX] Any support would be greatly appreciated. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Apr 24, 2024
The Rotary "Dial Shifter" keeps coming on while the vehicle is turned off as well as making a gear sound saying it's not in park when it is. I have had the vehicle for a month and I've had to jump the car 5 times already as it will come on and stay on. I looked it up and some fushions were recalled for it with the issue of that and the cd player and rear speakers making noise. Trying to see if another recall can be issued on more of the fusions.
Nov 05, 2023
+ 48 more complaints for this component
UNKNOWN OR OTHER
48 complaints
There is open recall for 2017 ford fusion coolant leak that may lead to vehicle fire i have the same issue with my 2017 ford fusion but my vin is not flagged now I’m scared to drive the vehicle
Jan 23, 2026
Vehicle display more often than not shows "Rear view camera not available" or a distorted image when reversing.
Dec 06, 2025
I recently bought a gear shift bushing cap for the cable since the cable is loose. I bought the part at Tasca Ford in Cranston, RI. The part was hard to find. It’s the same issue as the recall for the same car b ur years prior. Cap disintegrated since its plastic and next to the engine. The most recent part I bought that was used as genuine replacement has also disintegrated. I can see the pieces of it corroded. I need to buy another one but it’s going to happen again since it’s a faulty design. The first time it happened months ago caused my car to go into park. I couldn’t move it out of the way in the street. It would let me put it in neutral. The second time it happened today the car got stuck in neutral and it took many tries to get it into park. Everything is in tact except the plastic bushing cap and part that clips the cable to the vehicle is corroded. Simple fix but unsafe and happens randomly.
Aug 27, 2025
The overheat light came on and antifreeze was leaking into the number 4 cylinder of the spark plug, sometimes it would lose a little power
Jun 28, 2025
No accident just looking to fix the recall
Jun 26, 2025
+ 43 more complaints for this component
SERVICE BRAKES, HYDRAULIC
40 complaints
The contact owns a 2017 Ford Fusion. The contact stated while driving approximately 30 MPH and attempting to decelerate, the brake pedal was depressed to the floorboard. There was no resistance from the brake pedal. The contact was able to coast to Firestone parking lot. The vehicle was inspected by an independent mechanic who diagnosed that the driver’s side rear brake hose had fractured, and lost brake fluid. Additionally, the passenger’s side brake hose showed a possible fracture. The rear brake hoses were replaced. The manufacturer was made aware of the failure and confirmed that NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) only included the front brake hoses. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 100,900.
Jun 25, 2024
The contact owned a 2017 Ford Fusion. The contact stated that while driving at approximately 40 MPH and depressing the brake pedal, the vehicle failed to respond. The vehicle hit a stop sign, which flew and hit the passenger's side window of the vehicle. The vehicle then hit a privacy fence and crashed into an electrical pole. The air bags failed to respond. The contact stated that she hit her chest against the steering wheel and hit the back of her head against the front driver's side seat headrest. The contact's husband arrived at the scene and transported the contact to the residence. The contact was later taken to the hospital, where she was informed that she had sustained loss of 20 percent of her hearing, loss of smell and taste, and intermittent dizziness due to an internal fluid leak in the back of her head. The contact was still receiving medical assistance. A police report was filed. The vehicle was towed and totaled. The contact later received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic), which she related to the failure. The dealer was not notified of the failure. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 60,000.
Jun 13, 2024
The contact owns a 2017 Ford Fusion. The contact stated that upon depressing the brake pedal, she heard an abnormal pop. After which, the brake pedal went all the way to the floorboard. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the brake hose. The vehicle was repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic); the VIN was included, and parts were available. The manufacturer was not notified of the failure. The failure mileage was 134,000.
Apr 18, 2024
The contact owns a 2017 Ford Fusion. The contact stated that while driving at approximately 45 MPH, the brake pedal was depressed but failed to respond. There were no warning lights illuminated. The driver crashed into the sidewalk and damaged the front end of the vehicle. The vehicle was towed to the residence. There were no reported injuries. A police report was filed. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The contact stated that the failure was related to NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic). The manufacturer was not contacted. The failure mileage was approximately 79,418.
Oct 16, 2023
The contact’s husband owns a 2017 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that while her husband was driving at an undisclosed speed, he depressed the brake pedal, and the vehicle failed to stop. The contact’s husband applied pressure to the brake pedal and the brake pedal extended to the floorboard and the vehicle coasted to a stop. The brake fluid light and other unknown warning lights were illuminated. The driver was able to navigate the vehicle to safety. The contact stated that upon her husband inspecting the vehicle, there was brake fluid leaking on the ground. The vehicle was towed to an independent mechanic where it was diagnosed and determined that the front driver’s side brake hose had ruptured and needed to be replaced. The vehicle was repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 61,136.
Oct 02, 2023
+ 35 more complaints for this component
STEERING
38 complaints
The contact owns a 2017 Ford Fusion. The contact stated that the steering wheel was loose. The contact was able to rock the steering wheel approximately 3/8 of an inch in either direction. There was no warning light illuminated. The contact researched online and related the failure to NHTSA Campaign Number: 18V167000 (Steering). The contact called a local dealer and was advised that the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was informed of the failure and confirmed that the VIN was not included. The failure mileage was approximately 100,000.
Nov 12, 2025
The contact owns a 2017 Ford Fusion. The contact stated while driving 50 MPH and making a left turn, the power steering failed to function as intended. The contact stated that the steering wheel had seized and became difficult to maneuver. The vehicle was taken to the dealer where it was diagnosed with rack and pinon failure. The contact was informed that the rack and pinion needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 69,236.
Aug 15, 2024
The contact owns a 2017 Ford Fusion. The contact stated that while driving at an undisclosed speed, he became aware that the electronic power steering was not functioning properly. The power steering assist warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the steering rack. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 18V167000 (Steering) but the VIN was not included. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 69,000.
Mar 06, 2024
The shifter cable bushing was no longer present and the shifter cable detached, causing my car to be unable to move out of park. I was actively driving the vehicle, backing it out when this happened, leaving me and my car stuck in the middle of the lane. This problem has caused a recall on earlier years of the car, making it a known issue. There were no symptoms prior to the problem, but many warning lights on the dash claiming to need repairs immediately following the incident.
Feb 25, 2024
I was driving my car one day and the power steering fault message popped up on my dash of my car. So I turned around and went home. I turned the car off and then turn the car back on. Then the power steering fault message showed up with other warning messages. So I tried turning the steering wheel and noticed there was no power steering at all. So the next day I had it towed to the Ford dealer to have them look at it and fix the issue. They ended up replacing the rack and pinion and the power steering motor. When I picked the car up I asked the service person if it was a common part that broke on the car and he said it was a common part that broke. I was surprised that they had that specific part in stock when they told me the problem. Also I was not happy that I had to $4,400.00 to fix it. In my mind if it is a common part that breaks then why hasn't been a recall on that part.
Dec 16, 2023
+ 33 more complaints for this component
SERVICE BRAKES
25 complaints
On June 23, 2025, while departing my residence, I disengaged the emergency brake on my vehicle, subsequently hearing an unusual sound. Upon attempting to drive, I experienced diminished braking performance, and the brake warning indicator illuminated. The following day, I sought a professional assessment at Big O Tires. Their diagnosis identified a failure in the left brake hose, recommending the replacement of both. Following their recommendation, I proceeded with the necessary repairs. Subsequently, I received notification of a manufacturer recall addressing this specific issue. Consequently, I am seeking reimbursement for the previously completed service. Despite my attempts to obtain a resolution through direct communication, I have yet to receive a response, and I am now seeking assistance in this matter.
Jul 19, 2025
When my wife returned home from shopping she parked in the driveway I was going out so I had to move her car to get to mine. I saw a puddle of brake fluid on the ground and the brake light was on there was no fluid in the master cylinder . the car was towed to my mechanic and he found a rotted brake in the rear of the car up between the gas tank and rear seat right under a rubber clamp that holds the line this could have caused a tragedy. I connected Ford they said rusted brake lines are not covered even though they are coated.
Jun 30, 2025
I was driving under the posted speed limit on a road near my house going to pick my kids up from school. I was approaching a stop sign at an intersection and began to press on the brake pedal. The pedal traveled all the way to the floor as I was coming yo the stop sign. A driver was approaching me from the left headed east and my car went into the street past the stop sign and the other driver hit me which in turn caused his vehicle to roll over and mine was damaged as well which turned out to be totaled. The brakes began to work again right as the gentleman hit me. I never knew about the recall and when that happened I got onto the web and out in my VIN and saw it was recalled. I need to know what’s going to be dealt with here!
Mar 27, 2025
Back brakes are making a very loud noises and it’s hard breaking to come to complete stop
Mar 16, 2024
L/S Brake Hose Rear Replacement needed. Brake fluid leak rear caliper and brake hose and line rear flexible hose is split and leaking. Only Front brake hose was recalled when all brake all lines need to be replaced.
Jan 15, 2024
+ 20 more complaints for this component
AIR BAGS
23 complaints
The dash deteriorated to the extent that, according to a Ford engineer, the passenger airbag will not deploy properly.
Apr 24, 2024
I was a victim in a car crash driving this vehicle when another vehicle hit me and deployed my air bags. Due to the air bags deployment I ended up with significant burn marks to my arm which is likely to permanently scar.
Sep 07, 2023
The contact owns a 2017 Ford Fusion. The contact stated that the air bag module had failed and needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure and confirmed there was no recall on the VIN related to the failure. The approximate failure mileage was 89,000.
Aug 30, 2023
The contact owns a 2017 Ford Fusion. The contact stated that during a vehicle State Inspection, the air bag warning light illuminated. The vehicle was taken to an independent mechanic, who determined that the air bag control module needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but confirmed that the replacement part was on backorder. The failure mileage was unknown.
Jul 13, 2023
The airbag warning light was enabled on the dashboard. The Ford dealer diagnosed this as code "DTC U2100:00 and B00A0:62-28 stored in RCM". I was told that Ford told the dealer to reprogram the RCM with new software and this was labor "not covered by warranty or recall." But, if my car were one model year later (2018 vs 2017) it would have been covered. I argued that this is a software defect, clearly the hardware did not fail since they did not have to replace anything, but I was simply told the labor was not covered and I would need to pay for it. After the software update the error codes and airbag light are normal. There is clearly a software defect impacting the safety performance of the vehicle. This vehicle should be recalled and the cost of the update and labor should not be a burden to the consumer. Consumers, such as me, who have had to pay for this work should be reimbursed by Ford.
May 23, 2023
+ 18 more complaints for this component
ENGINE AND ENGINE COOLING,ENGINE
22 complaints
The contact owns a 2017 Ford Fusion. The contact stated while driving at an undisclosed speed, the vehicle jolted and there was white smoke coming from the exhaust pipes. The vehicle was taken to a local independent mechanic where it was diagnosed with a coolant intrusion and a blown head gasket. The mechanic related the failure to the Customer Satisfaction Program: 21N12. The local dealer was contacted; however, the vehicle was not diagnosed or repaired because the VIN was not under recall. The manufacturer was made aware of the failure. The failure mileage was approximately 95,000.
Jun 24, 2025
The contact owns a 2017 Ford Fusion. The contact stated that while driving on several occasions at various speeds, the vehicle started sputtering with the check engine warning light illuminated. The vehicle was taken to dealer where it was diagnosed and determined that there was coolant intrusion into the engine and the engine needed to be replaced. The manufacturer was notified the failure. The failure mileage was 50,000.
Jun 06, 2025
The contact owns a 2017 Ford Fusion. The contact stated that while driving on several occasions at various speeds, the vehicle lost motive power with a misfire coming from the engine. The vehicle was driven to the residence. The contact stated that the next day, when the vehicle was started, the check engine warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with a misfire coming from the spark plugs. The vehicle was taken to the residence. The contact stated that while driving to the residence, the temperature gauge went to Hot. The contact checked the coolant reservoir and became aware that the coolant reservoir was empty. The contact added coolant. The following morning the vehicle was started, and there was white smoke coming from the exhaust pipe. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 47,000.
May 27, 2025
The contact owns a 2017 Ford Fusion. The contact stated that upon starting the vehicle, the engine was shaking abnormally, with the check engine warning light illuminated. The contact checked the engine bay and noticed that the coolant reservoir was abnormally low level on coolant. The vehicle was taken to a local dealer and the contact was informed that there was a misfire in cylinder #3 due to coolant intrusion in the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 49,000.
Mar 04, 2025
The contact owns a 2017 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle started to hesitate while depressing the accelerator pedal. The check engine warning light was illuminated. Due to the failure, the vehicle was towed to a local dealer. The vehicle was diagnosed with engine failure due to coolant intrusion into one of the cylinders. The contact was provided an estimate for the repair. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The vehicle remained in the possession of the dealer but was not repaired. The failure mileage was approximately 74,000.
Jan 28, 2025
+ 17 more complaints for this component
POWER TRAIN,ENGINE
21 complaints
Technical Safety Bulletin 19-2346; coolant infiltrating cylinder #2. Quoted $8350 for long block repair.
Nov 04, 2025
When turned on airconditioner car shuddered engine light came on started blowing white smoke alot and blow buy engine oil in crank case
Sep 15, 2025
While driving on the highway at 60MPH, the check engine light came on first, then got an overheating issue. Let car cool, then drove city streets and took car to an independent auto repair shop. They read the engine and it had error code P0304. Shop bore scoped into cylinder 4 and found engine coolant. Took to dealer to confirm, they did find that engine coolant was leaking into cylinder 4 and recommended replacing engine long block assembly for $9.25k.
Oct 17, 2024
2017 Ford Fusion Titanium 2.0L Ecoboost purchased brand new. Coolant intrusion into Cylinder #1, causing a misfire,registered in Vehicle Health Alert system; check engine light on. Liberty Ford dealership was notified within the first week of the 1st misfire. Autozone found fault code P0301. Code scanner suggested replacing cylinder #1 spark plug. If misfire cont., it stated to replace Coil on cyl #1. All four spark plugs were replaced and Coil for cylinder #1 was replaced. Veh.began to exhibit a low coolant level, white exhaust smoke & rough running. Coolant fumes were entering the veh. cabin. Coolant added as soon as "Engine Coolant Over Temperature" dash alert. Diagnostic completed at Firestone Complete Auto Care: Determined "Cyl 1 is full of coolant & misfire occurring due to engine burning coolant.TSB out for this issue stating engine block replacement will be needed. Recommend dealership*** Manufacturer's recommended maintenance.… They provided a copy of TSB 22-2229 and stated Ford Manufacturer should replace entire engine (Long Block). I contacted Ford Manufacturer. They stated several times that "this is a KNOWN ISSUE". They stated a diagnostic must be done by a Ford Dealership and submit financial asst. request. They found code P0301 as well as overheating codes are present, coolant level low. Mode 6 shows multiple misfires on cyl1...found same diagnosis. TSB 22-2229 covers this condition, engine build code is 910 and meets criteria." Veh avail for inspection upon request? The veh stranded me away from home 2-4 times. I was given literature that stated low coolant may automatically shut off the engine, even while driving. Antifreeze contains glycols & other liquid chemicals that are sweet smelling but POISONOUS. That entering the veh cabin can possibly cause a person to have damage to the central nervous system, lose consciousness, become nauseated, vomit, dizzy, etc. Ford didn’t notify me of the manufacturer fault that caused the issue, a 3rd party did.
Sep 03, 2024
The contact owns a 2017 Ford Fusion. The contact stated that while driving at an undisclosed speed, the transmission experienced rough shifting from first to second gear. Additionally, the engine was misfiring. The check engine warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed that the transmission needed to be replaced. The vehicle was then taken to two other independent mechanics, and it was determined that the transmission needed to be replaced as well as the engine due to coolant intrusion into the engine. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 60,790.
Aug 02, 2024
+ 16 more complaints for this component
WHEELS
19 complaints
The contact owns a 2017 Ford Fusion. The contact stated that while pulled over on the shoulder and attempting to change a tire, the contact was unable to remove the lug nuts to change the tire. The vehicle was taken to a dealer and the vehicle was diagnosed with faulty lug nuts. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 71,000.
Apr 11, 2024
The contact owns a 2017 Ford Fusion. The vehicle was taken to the local dealer to be repaired under NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) however, the contact was informed by the mechanic that the lug nuts were defective. The lug nuts were replaced. The manufacturer was contacted but no assistance was provided. The failure mileage was approximately 54,042.
Nov 24, 2023
The contact owns a 2017 Ford Fusion. The contact stated that while driving at an unknown speed, she noticed there was a nail in the passenger’s side tire. The low tire pressure warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the lug nuts were swollen and that the rim was damaged during removal. The tire also had a slow leak. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 42,000.
Jul 31, 2023
The contact owns a 2017 Ford Fusion. The contact stated during routine maintenance, the dealer informed the contact that all four lug nuts needed to be replaced. The contact was advised by the dealer that the lug nuts could shear off while driving, causing the wheel to detach and the driver would lose control of the vehicle. The contact had the lug nuts replaced. The vehicle was repaired. The contact stated that the lug nuts were the original parts. The manufacturer had been informed of the failure. The failure mileage was approximately 16,000.
Jul 13, 2023
The Ford dealer told me that my 2017 Ford Fusion has "swollen lug nuts" and must be replaced. They said that there is a potential for the lug nuts to fail and the wheel would fall off while driving. This will be at my own expense. My car has less than 22,000 miles on it and I feel that this a design/manufacturing issue on the part of Ford Motor Company.
Jun 19, 2023
+ 14 more complaints for this component
POWER TRAIN,UNKNOWN OR OTHER
12 complaints
When parking i attempted to put the vehicle in reverse and a warning light came on "shift system failure", and the shifter cable locked in placed flashing causing the car to lock without the ability to move. Shift cable bushing is split causing dislodge from the fitting
May 20, 2025
Over the last 11 months when I am driving I go to back into a parking spot and the gear shifter gets stuck in neutral and will not move. I have to turn the vehicle off and turn it back on to move it. This leaves me sitting in the middle of the parking lot at risk to get hit
May 16, 2023
On 12/08/2022, my 2017 Ford Fusion started as normal in a busy parking lot, but once I idled/moved just a little, it became locked as if the emergency brake was on (it was not) and would not shift out of park, regardless of trying to put in neutral, reverse, etc. (It would show N or R on the dash, but remained deadlocked in Park.) There was this error message: "SHIFT SYS FAULT Service Required." It took several people to push the car to a safe area out of the way of traffic. Had to have the car towed at owner's expense to the closest Ford dealership. There were not other messages or signs of the problem prior to this failure on 12/08/2022. Ford dealer on 12/10/2022 removed and replaced transmission shifter cable bushing and installed cap. Ford dealer agreed that most certainly, this 2017 Ford Fusion has the EXACT same recall #22s43 that other 2017 Fusions have had. However, when Ford dealer entered this vehicle VIN, nothing showed up in OASIS. So I had to pay for this repair out of pocket. Like others have stated, the Ford recall #22s43 is too narrow in scope. So why in the world am I having to pay 100% of the cost to fix the EXACT SAME bushing/cap issue (recall 22s43) that others are having with the EXACT SAME YEAR, MAKE, & MODEL?!?! Just because my VIN wasn't included in Ford's original recall? DOES NOT MAKE SENSE! If it's the same issue as the other vehicles are having (of the same year, make, model) why am I paying for the error and they aren't?
Jan 11, 2023
The contact owns a 2017 Ford Fusion. The contact stated while attempting to reverse, the vehicle failed to move. The vehicle failed to shift into park and neutral without warning. The vehicle was taken to the local dealer however, the mechanic was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The approximate failure mileage was 44,469.
Dec 13, 2021
TRANSMISSION BECOMING UNPLUGGED CAUSING VEHICLE TO NOT SHIFT PROPERLY OR NOT AT ALL. VEHICLE WAS PUT INTO REVERSE MADE IT ABOUT 5 FEET AND COULDN'T SHIFT INTO ANY OTHER GEAR AFTER THAT.
Mar 30, 2021
+ 7 more complaints for this component
ENGINE,ENGINE AND ENGINE COOLING
8 complaints
The contact owns a 2017 Ford Fusion. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The contact took the vehicle to an independent mechanic to be diagnosed. The contact was informed that the spark plugs needed to be replaced. The spark plugs were replaced; however, the following day the check engine warning light illuminated again. The vehicle was taken to the dealer where it was diagnosed with coolant leaking into the engine, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 51,000.
May 22, 2024
While driving on the interstate car began to excessively shake and check engine light flashed for almost a minute then stopped. Was approaching exit to residence location and was able to get there. Once at home, car was then sluggish to start but no check engine light was on. Attempted to drive car in a safe area to see if it would repeat or light would come on. This was on a Sunday, therefore the dealership was closed. Light did come back on solidly and took car to dealership that next day, Monday. Was told coolant intrusion into the engine. After the incident and in doing research, appears to be a known issue in this vehicle.
Apr 02, 2024
Coolant intrusion - coolant leaking into the motor because of the engine block design and the head gasket failing. Can cause fire
Mar 26, 2024
Coolant Intrusion on Cylinder 1, common problem amongst 2.0 Ecoboost Engine. Current Ford fix is replace engine block with a new design. Ford is aware of the design flaw in these cars and refuses to make things right with current owners.
Feb 22, 2024
The contact owns a 2017 Ford Fusion. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated on the instrument panel. The vehicle was taken to the dealer, who diagnosed a failure with the spark plugs. The vehicle was repaired, but the failure reoccurred. The vehicle was taken back to the dealer, and it was determined that there was a misfire in cylinder #3 due to low compression. The vehicle was not repaired. After investigating the failure, the contact related the failure to Technical Service Bulletin: 19-2243. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 112,000.
Jan 10, 2024
+ 3 more complaints for this component
POWER TRAIN,ELECTRICAL SYSTEM
6 complaints
The contact owns a 2017 Ford Fusion. The contact stated while the vehicle was parked, the contact connected the battery to the charger and the dead cell warning light illuminated. In addition, the contact stated that the battery failed to charge. The contact stated that even though the vehicle was not started, the gear shifter independently switched from park and reverse. The contact stated when the vehicle started, the vehicle rolled backwards several feet. The contact stated that the failure almost caused him to be pinned up against the wall of the garage, where the vehicle was parked. The contact stated that he used the parking brake to stop the vehicle from moving. The vehicle was towed to the dealer; however, the failure could not be duplicated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 33,500.
Sep 09, 2024
When putting my car in park, I received a warning "SHIFT SYS FAULT" Confirm Park Brake Apply Before Exiting the Vehicle. My parking brake was never on. When I got back in my vehicle, my gear shift would not let me take put my vehicle into gear. I googled and found it was the gear shift bushing and there was a recall on this part. I was able to take my vehicle to the repair shop and told them there was a recall. They informed me the recall was not for my vehicle because the recall was for automatic transmissions on 2016 and before. How can this exact same part be a recall on an automatic vehicle, but not on an electronic "dial" gear shift?
Dec 16, 2022
As I was driving my check engine light came on and my car started to jerk. I had some previous issues with my AC and radio delays. I took the car to the dealer and he said my PCM was missing a ground and if I continued to drive it the engine could catch fire. The car is only 5 years old. He says they have seen this a lot in these cars.
Oct 27, 2022
I WAS IN A THE MIDDLE OF A DRIVE THRU AND I PUT MY CAR IN PARK AND ENGINE LIGHT CAME ON, MY GEAR SHIFTER WAS FLASHING IN ALL THE GEARS AND ON THE DASH IT WAS SAYING SHIFT SYSTEM FAULT SERVICE REQUIRED. I COULDN'T PUT IT IN ANY GEAR. IT WOULDN'T START UNTIL SOME GUY CAME OVER AND SAID THE SAME THING HAPPENED TO HIS FORD FUSION. HE KNEW HOW TO GET IT BACK IN PARK AND SHOWED ME WHAT HAPPENED. HE HAS SAID THAT THERE WAS A RECALL FOR THAT PART.
Sep 08, 2020
SO, I HAVE COMPLAINED TO FORD ON 3 SEPARATE OCCASIONS ABOUT MY GEAR SHIFT MALFUNCTIONING. WHEN I PUT IT INTO DRIVE, THE GEAR WILL GO BACK INTO PARK AND START FLASHING. OR IT WILL START DRIVING AND GO BACK INTO PARK AFTER MOVING. IT'S CRAZY. THEN, FORD SERVICE HAS TOLD ME MULTIPLE TIMES THAT THEY CAN'T FIND ANYTHING WRONG. NOW THERE IS A RECALL FOR THE EXACT SAME ISSUE. I EVEN HAD WANTED THEM TO TAKE THE CAR BACK BECAUSE I DIDN'T FEEL SAFE, BUT THEY SAID IT HADN'T BEEN LONG ENOUGH AND THEY COULDN'T FIND ANYTHING WRONG. AGAIN, NOW THERE IS A RECALL FOR THE EXACT ISSUE. ALSO, MY WINDOWS ROLL BACK DOWN AFTER I ROLL THEM UP. THEY WILL DO THIS SEVERAL TIMES UNTIL THEY STOP. AGAIN, FORD SAID THEY CAN'T FIND ANYTHING WRONG.
May 15, 2019
+ 1 more complaint for this component
ELECTRICAL SYSTEM,UNKNOWN OR OTHER
6 complaints
Shift system failure. 2023 replace plastic piece that was not a recall on 27 but was a recall on all other models. Last week shift system failure $706 to replace shifter picked up car Saturday. Today car is being towed back for shift system failure again. Car will not go out of park. I have all receipts and invoices from.
Jul 16, 2024
The shift dial (park, neutral, drive, reverse), makes a continuous spin noise like it's stuck and trying to turn, but can't. This is the second time this is happening. I had it fixed the first time at the Ford dealership, and was short one year in the Recall group. 2017 year should have been included in that recall. After they fixed it, now the issue has returned. This issue results in the driver not being able to move in reverse. Therefore, you're stuck and unable to back up if needed. There are no warning lights. The only warning you get is when the rattling noise starts.
Apr 22, 2024
The car will not shift. The car will start but I cannot shift from Park to neutral or drive
Apr 10, 2022
RANDOMLY UPON STARTING THE CAR NONE OF THE DASHBOARD CONTROLS WORK INCLUDING HVAC CONTROLS, RADIO OR WINDOW CONTROLS, MEMORY SEATS ALSO.
Jan 21, 2019
MY 2017 FUSION HAS COMPLETELY STALLED ON 2 DIFFERENT OCCASIONS WHILE DRIVING. THE LATEST INCIDENT OCCURRED ON 3/4/18. AS I PROCEEDED TO MAKE A LEFT TURN AT A BUSY INTERSECTION..THE CAR SHUT OFF WITH NO WARNING. WE WERE ALMOST REAR ENDED BY ANOTHER PERSON. THE CAR WOULD NOT START UNTIL SOMEONE GAVE US A BOOST. MY HAZARDS WERE ALSO INEFFECTIVE. MY CAR STAYED AT THE BRONDE FORD DEALERSHIP FOR 4 DAYS AND THEY SAID THAT THERE WERE NO CODES SO THERE ARE NO PROBLEMS. MY CHILD AND I WERE IN GRAVE DANGER AND STILL IN DANGER BECAUSE THEY CAN'T FIND A SOLUTION. I'M TERRIFIED TO DRIVE WITH MY BABY.
Mar 13, 2018
+ 1 more complaint for this component
ELECTRICAL SYSTEM,ENGINE
6 complaints
Loses power .. Cylinder misfire P0301 Diagnostics
Oct 22, 2021
I WAS DRIVING ABOUT 10 MINS AWAY FROM MY HOUSE, IN THE CITY AS I APPROACHED A RED LIGHT MY CAR SHUT OFF. IT STOPPED WHILE I WAS IN MOTION , I COULDN'T BRAKE, THERES WAS NOTHING COULD DO BUT JUST LET THE CAR STOP ON ITS OWN. THE BATTERY LIGHT STARTED TO FLASH, THE WRENCH LIGHT CAME ON. I TURNED THE CAR OFF, THEN BACK ON, AND IT DIDNT START. SO I TRIED AGAIN, AND THE CAR STARTED, I WAS ALE TO MAKE IT HOME SAFE. BUT THIS IS A HAZARD, I HAD CHILDREN IN THE CAR, I WILL LIKE THIS CAR TO BE RECALLED. I SAW IN 2017 IN JULY ABOUT FIVE THOUSANDS 2017 FORDS WERE RECALLED FOR THIS REASON. IM SCARED AND DONT KNOW WHAT TO DO!
Sep 01, 2020
I PURCHASED THE CAR ON OCTOBER 21ST OF 2019. I HAVE HAD NOTHING BUT ISSUES WITH THIS CAR BASICALLY SENSE PURCHASING IT. I BOUGHT THE CAR WITH 54,000 MILES. I WAS UP TO ABOUT 74,000 WITH THE NEED TO REPLACE A MOTOR. I DID SO, BEFORE I REPLACED THE MOTOR THE BATTERY LIGHT WAS ON. I CHANGED THE ALTERNATOR BELIEVING THAT WOULD BE THE ISSUE, I ALSO REPLACED THE BELT WITH IT THINKING I MIGHT AS WELL. STILL BATTERY LIGHT WAS ON. SO I EVEN WENT AND CHANGED THE BATTERY AND STILL A BATTERY LIGHT. I HAVE DUMPED NOTHING BUT MONEY INTO THIS CAR SENSE PURCHASING IT. I HAVE BEEN READING NOTHING BUT ISSUES WITH THESE 2017 FORD FUSIONS ANS BELIEVE FORD NEEDS TO BE HELD ACCOUNTABLE FOR THIS BECAUSE SO MANY OTHERS ARE EXPERIENCING THESE ISSUES AND NOW I BELIEVE THE ECM IS GOING TO BE REPLACED. I BOUGHT THIS CAR THINKING A NEW CAR WOULD BE A GOOD INVESTMENT FOR MY FAMILY AND TO GO BACK AND FOURTH TO WORK WHICH HAS BEEN NOT THE CASE. I HAVE HAD OLD WAR HORSE TRUCKS WITH OVER 200K MILES RUN AND DRIVE BUT KNEW THEY WOULD NEED TO UPGRADED TO A NEWER FAMILY CAR. I REALLY DO NOT THINK FORD IS TAKING ACCOUNT FOR THE REAL ISSUES THEY ARE HAVING WITH THEIR NEW VEHICLES THEY ARE SELLING TO THE PUBLIC WHO ARE TRYING TO MAKE A LIVING AND WITH CONSTANT ELECTRICAL PROBLEMS THAT JUST ISN'T RIGHT. BASIC MAINTENANCE IS UNDERSTANDABLE BUT TO HAVE ALL OF THESE ISSUES JUST SEEMS UNACCEPTABLE.
Jul 27, 2020
SINCE I BOUGHT THE CAR IN MARCH OF 2019 IT HAS GIVEN ME PROBLEMS WITH STARTING. IT SEEMS THE BATTERY IS ALWAYS DEAD EVEN WHEN THE BATTERY IS NEW AND THE MECHANIC TELLS ME THE BATTERY IS CHARGED FINALLY TODAY A MECHANIC TOLD ME IT MAY BE THE STARTER. BECAUSE WHEN I TRY TO START IT MOST TIMES IT IS DELAYED OR SOMETIMES IT WON'T START AND I NEED A JUMP . THIS CAR IS ONLY 2 YEARS OLD. WHY AM I HAVING PROBLEMS WITH THE STARTER ? IS THERE A RECALL ON THIS CAR?
Jan 12, 2020
TL* THE CONTACT OWNS A 2017 FORD FUSION. ON SEVERAL OCCASIONS, WHILE DRIVING BETWEEN 30 AND 70 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO MANLEY'S BELVIDERE FORD LINCOLN (1800 N STATE ST, BELVIDERE, IL 61008, (815) 544-2138) TO BE DIAGNOSED, BUT THE MECHANIC WAS UNABLE TO RETRIEVE A FAULT CODE. THE CONTACT WAS INFORMED THAT A SOFTWARE UPDATE WAS PERFORMED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER: CAS-22298025. THE APPROXIMATE FAILURE MILEAGE WAS 21,108.
Sep 19, 2019
+ 1 more complaint for this component
ENGINE,FUEL/PROPULSION SYSTEM
5 complaints
Coolant leaking into cylinder, causing sudden rough driving, engine overheating warnings that don’t match temperature readings and distract driving.
Jan 12, 2026
The temp gauge suddenly jumped up and alert said coolant was low. Driving on freeway, car shut down before I could get into a shoulder. Big rigs swerving around me, could have been killed. No leaks under car. Cap off the coolant reservoir and the coolant level bubbles up back to normal. After that, even driving one mile makes the temp gauge jump up and drop down erratically. Quoted more thank $8,000 to repair because it requires a new engine? Ford dealership said this is very common issue for Ford Fusions, that it is a design flaw and many of their clients have had similar safety scares.
May 11, 2025
All right, so I have a little bit of bad news for you, so we hooked up a code reader to the car. And there were a couple of misfires. So there's a cylinder to misfire a cylinder or a random misfire detected, a cylinder 3, misfire a cylinder one misfire. So our service advisor thinks that it's probably not an issue with a coolant. An issue with the head gasket, and he would recommend that that gets replaced. And he said, at some point, you might need to replace the entire engine.
Aug 01, 2022
AS I WAS DRIVING ON THE HIGHWAY MY CAR ENGINE STARTED CUTTING OUT AND CHECK ENGINE LIGHT CAME ON. REPLACED SPARK PLUGS, FUEL FILTER AND COIL PACK. PROBLEM DID NOT RESOLVE. TOOK CAR TO CHAPMAN FORD IN SCOTTSDALE AZ. THEY FOUND THAT THE FUEL INJECTOR IN CYLINDER 2 HAD STUCK OPEN FLOODING THE CYLINDER WITH GASOLINE AND COMPROMISING LUBRICATION IN THAT CYLINDER. REPAIR REQUIRES REMOVING ENGINE AND REBUILDING IT. VEHICLE ONLY HAS 70,000 MILES ON IT OF WHICH 95% IS HIGHWAY MILES. IF I WOULDN'T HAVE KNOWN TO SWITCH IT TO SPORT MODE AND KEEP THE RPM UP UNTIL I COULD GET TO A SAFE LOCATION IT COULD HAVE STALLED ON THE HIGHWAY CAUSING A COLLISION. AFTER DOING RESEARCH ONLINE FOUND THAT THIS IS A COMMON PROBLEM WITH THE ECOBOOST 4 CYLINDER MOTOR AND SHOULD BE A RECALL ITEM. FORD REFUSING TO PAY FOR REPAIRS ON A CAR THAT'S JUST OVER 2 YEARS OLD. WITH PREVIOUS FORD VEHICLES I HAVE ALWAYS BEEN OFFERED AN EXTENDED WARRANTY BUT WAS NOT ON THIS VEHICLE.
May 22, 2019
WHILE DRIVING MY CAR THERE IS AN ODOR THAT SMELLS LIKE GAS. I AM NOT SURE WHERE IT IS COMING FROM SOMETIMES IT'S VERY STRONG OTHERS NOT SO BAD
Sep 25, 2017
SEAT BELTS
5 complaints
The contact owns a 2017 Ford Fusion Energi. The contact stated while parked and attempting to fasten the rear passenger's side and driver's side seat belts, the seat belts failed to retract. The vehicle was taken to a dealer but was not diagnosed or repaired. The manufacturer was notified of the failure and informed the contact that the seat belts could not be ordered because the seat belts had been discontinued. The approximate mileage was 70,000.
Nov 05, 2024
Front driver and passenger seat belts do not lock or retract. Mine and my children life are at risk because it’s a safety issue, and requirement to have a seatbelt worn while driving but as well having a proper working seatbelt. Yes, the car is currently at the dealer now which confirmed it does not work properly. No warning lights came on to let me know that the seat belt was malfunctioning.
Mar 07, 2023
WHILE CROSSING AN INTERSECTION I WAS HIT ON MY DRIVER'S REAR DOOR AND MY SEATBELT UNLATCHED AND I WAS THROWN OUT THE DRIVER'S SIDE DOOR.*DT*JB
Feb 19, 2021
THE SEATBELT HAS CAME APART INSIDE. YOU CAN LOOK INSIDE THE ONE THAT'S BROKEN AND THE GOOD ONE AND SEE THERE IS A PIECE MISSING OR BROKEN.
Feb 01, 2020
THE REAR SEATBELTS RATCHET DOWN CONTINUOUSLY CAUSING THE REAR PASSENGERS TO HAVE TO TAKE THEM OFF AND REBUCKLE THEM.
Nov 08, 2019
FUEL/PROPULSION SYSTEM
5 complaints
According to repair shop check engine light will remain on as anti freeze leaks due to a malfunction in my car. Repair shop states this is not a recall as it is not a safety issue and yet when I put on gas peddle car doesn't auto engage to proper speed. I also don't see how coolant leaking on engine wouldn't be safety issue.
Sep 29, 2024
My vehicle is displaying severe symptoms as well as throwing code of the already noted recall for other trims of this car but my car isn’t on recall list. I’ve had to replace the canister purge valve 3 times in less than 2 years, the vacuum seal is affecting fuel tank and honking every 15-20 seconds…when canister gets stuck open, I can’t start my car which happened yesterday in a busy intersection. It’s dangerous and I’m afraid to transport my kids in my car.
Feb 19, 2024
humming sounds from gas tank. Car stalls and difficult to crank when getting fuel. Car has a horrible smell from gas fumes.
Sep 04, 2023
Canister Purge Valve (CPV)” in this vehicle malfunctioned before reaching 75k, becoming stuck in an open position, which could create an excessive vacuum in the fuel vapor management system. Resulting in check engine low speed stalling and gas tank vacuum
Apr 03, 2022
My gas tank does this sucking noise and it's been fixed once but it keeps having this same issue and cuts my car off. It takes 15 to 30 minutes before it starts up again. When I looked up the issue I noticed other for fusions had been having the same problems.
Mar 01, 2022
ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE
4 complaints
What malfunctioned- Car did not give any notice that it was in engine failure for months other than under performing and upon taking it to the ford dealership was never helped with the problem they took money for an oil change and works package but failed to make sure my car was safe. My car was a safety hazard bc it gave zero warning that it was loosing power and when the engine did fail I knew something had been wrong for almost a year and felt it went ignored by Ford and was taken advantage of. The product has been confirmed by multiple mechanics that what causes it is the hose cracks and thus the engine coolant wrecks a working engine. Ford knows it’s a problem but isn’t acknowledging it and makes more money off of parts.
Jul 22, 2025
TURNED CAR ON AND IMMEDIATELY RECEIVED THE SHIFT SYS FAULT SERVICE REQUIRED WARNING. CAR WOULD NOT GO INTO GEAR AS WELL AS THE PARKING BRAKE WOULD NOT GO OFF. ATTEMPTED TO UTILIZE THE KEY HOLE IN THE CENTER CONSOLE, DID NOT ASSIST AT ALL. TOW TRUCK MOVED CAR TO THE HOUSE FOR US. THE CAR WAS STATIONARY DURING THE ATTEMPTING TO MOVE INTO DRIVE.
Jul 21, 2020
HAVE HAD CAR FOR JUST ONE YEAR 18676 MILES AND IT HAS TURNED OFF RANDOMLY 3 TIMES DURING THIS TIME. RANDOMLY UNDER LIGHT DRIVING CONDITIONS WHILE MAKING A TURN THE CAR LOOSES POWER AND WHEN YOU LOOK AT THE DASH IT SAYS FULL ACCESSORY LIKE YOU JUST PUSHED THE BUTTON WITH OUT TOUCHING THE BRAKE TO START. ONCE COASTED TO A SAFE LOCATION YOU CAN RESTART THE CAR AND EVERYTHING RUNS FINE. NO CODES ARE LOGGED WHEN THIS ISSUE OCCURS. THIS COULD BE A SERIOUS ISSUE AS YOU HAVE NO WARNING WHEN IT HAPPENS AND IT LEAVES THE CAR WITHOUT POWER.
Nov 29, 2017
I PURCHASED THIS CAR ON 8/31/16 AND ON 11/28/16 THE DREADED DEAD BATTERY PROBLEMS STARTED. I TOOK IN IT, THEY REPLACED THE BATTERY ON 11/28 SAID THAT IT WAS PROBABLY JUST A FAULTY BATTERY FROM THE MANUFACTURE AND THAT IT HAPPENS, RARELY BUT IT HAPPENS. ON 12/31/17 I WENT TO START MY CAR AND IT AGAIN WOULD NOT START. EACH TIME THAT THIS HAS HAPPENED, I HAVE TO MANUALLY UNLOCK MY CAR BY TAKING OFF A PIECE OF THE DOOR HANDLE TO EXPOSE THE KEY HOLE AND THE DOME LIGHTS OR DASH LIGHTS DO NOT COME ON, THAT'S MY DEAD GIVEAWAY THAT IT WONT START. WHEN I TOOK IT TO THE SHOP THIS TIME THEY INFORMED ME THAT THE CAR WAS MANUFACTURED ON 8/1/16 AND SAT TOO LONG WITHOUT BEING DRIVEN SO IT CAUSED THE BATTERY TO MESS UP(EVEN THOUGH I HAD THE BATTERY REPLACED A MONTH EARLIER, AND DRIVE EVERY SINGLE DAY TO WORK). I GOT THE CAR BACK AND I BET YOU CANT GUESS WHAT HAPPENED ON 2/4/17... MY CAR WAS DEAD. WOULDN'T START, WOULDN'T UNLOCK... DEAD. THIS TIME THEY WE'RE "99.9% SURE" THEY FIXED THE PROBLEM BY UPDATING MY POWER TRAIN CONTROL MODULE. THEY HADN'T, IT DIED AGAIN ON 5/22/17. WHEN I TOOK IT IN, THEY UPDATED THE POWERTRAIN CONTROL MODULE AND SENT ME ON MY WAY, SO I'M JUST WAITING FOR IT TO DIE AGAIN HONESTLY. THEN... I TOLD THEM MY TRANSMISSION IS SLIPPING ON 5/22/17- THEY IGNORED IT WHEN DOING UPDATES AND IT WASN'T RESOLVED. ON 6/13/17 I TOOK IT IN BECAUSE THE TRANSMISSION WAS STILL SLIPPING SO THEY UPDATED THE POWERTRAIN CONTROL MODULE AGAIN... DIDN'T FIX IT(OBVIOUSLY) AND THEN ON 6/22/17 I TOOK IT IN BECAUSE I ALMOST GOT INTO AN ACCIDENT DUE TO THE TRANSMISSION SLIPPING AND SLIDING MY CAR INTO ONCOMING TRAFFIC TRYING TO SHIRT GEARS(ITS AUTOMATIC) AND THEY REPLACED A PRESSURE VALVE, NOT SURE WHY YOU WOULD NEED TO REPLACE A PART LIKE THAT ON A BRAND NEW CAR ANYWAY, BUT THE TRANSMISSION STILL ACTS UP.
Jul 06, 2017
UNKNOWN OR OTHER,ENGINE
4 complaints
The engine on this vehicle needs to be replaced due to coolant intrusion into the cylinders. On my engine diagnosis I get Error Code #P0302 which indicates Cylinder 2 misfire detected. My vehicle overheats quickly, runs rough and the coolant reservoir is dry. The vehicle's exhaust blows out a lot of white-ish smoke with a sickening odor. I took my vehicle to my local Auto Nation Ford of Bellevue, WA service department. They told me it is what they have seen on a lot of Ford Eco-Boost engines and there was a recall on these for engine replacement but my 2017 vehicle falls out of the recall. They told me I need a new engine replaced in this vehicle to the cost of about $10,000. Auto Nation Ford Bellevue, WA's service department referenced service bulletin #22-2229 (Some 2015-2018 Edge and 2017-2019 Fusion/MKZ/Escape/MKC vehicles equipped with a 2.0L EcoBoost engine may exhibit a low coolant level, white exhaust smoke and/or a runs rough condition with or without an illuminated malfunction indicator lamp (MIL). Diagnostic trouble codes (DTCs) may include P0300, P0301-P0304, P0316, P0217, P1285 and/or P1299 stored in powertrain control module (PCM). This may be due to coolant intrusion into the cylinder. To correct the condition, follow the Service Procedure to replace the long block engine assembly.). There were no warnings or dashboard lights except when my coolant gauge rose suddenly while driving on the road. I have dutifully maintained my vehicle with regular checkups so I don't believe I am at fault for this problem. I believe the Ford Motor Company should have informed me of this chronic problem but they didn't. I also believe my 2017 Fusion should be repaired with the cost going to the Ford Motor Company for a known defect. What do I do now please?
Nov 14, 2024
I had the car about 3 months when the first service light appeared. Misfire - replaced the cylinder. But 2 months later service light came on again for same issue. Ford Dealership said it was coolant intrusion. Car repeatedly overheats. Service engine light comes on/stays on. Temperature gauge will indicate high temp, then will drop to normal seconds later, then shoot to the top again. At times engine will decrease power, and I have to pull over and park until engine cools, no matter where it happens. I don't feel safe driving on the highway, or any distance more than 20 miles or so. I am also afraid to park in the garage at night in case it's too hot. Ford dealership says it needs a new engine. Called Ford Customer Service but my VIN was not on the service action 19B37 or 21N12 (even though it was manufactured at a listed plant on the listed dates) so they would not assist in covering it.
Sep 19, 2024
Coolant leaking into engine. Engine block required entire replacement. Check engine light flashing causing me to contact Ford Dealer/Service. This was December 4, 2023.
Jan 29, 2024
THE CAR WOULD NOT START DUE TO THE THROTTLEBODY FAILED TO OPERATE. LUCKILY, THE CAR WAS PARKED WHEN THIS OCCURED AND HAD TO BE TOWED TO NEAREST FORD DEALER. WHO INFORMED ME IF I HAD BEEN DRIVING AND IT HAD FAILED DURING OPERATION, CAR WOULD HAVE COME TO A DEAD STOP WHILE DRIVING AND/OR IN MY CASE FAILED TO START. THEY SAID THROTTLEBODY GIVES THE ENGINE THE AIR IT NEEDS TO PREFORM. WE WERE OUT OF TOWN AND DUE TO DRIVE ON A MAIN HIGHWAY FOR TWO HUNDRED MILES AT 70MILES PER HOUR! I HAVE INCLUDED INVOICES FROM THE FORD DEALER, INVOICE FROM AUTO DEALER- WHO HAD REPAIRS DONE ON CAR, AND THE CARFAX REPORT-THAT DID NOT SHOW ANY THROTTLEBODY RECALLS OR REPAIRS, NOR DID THE AUTO DEALER'S REPORT. THE CAR WAS CERTIFIED FOR 21,953 MILES BY THE STATE OF FLORIDA AND CARFAX. HOW IS THAT A CAR'S THROTTLEBODY WOULD FAIL AFTER 21,000 MILES, UNLESS IT WAS ALREADY DEFECTIVE IN THE BEGINNING!?? THE REPORTS INDICATE THE VEHICLE WAS A 1 OWNER CAR AND 21,953 MILES WITH PASSING THRU TWO SYSTEMS AND NEVER DETECTED. I HAD ONLY OWED THE CAR FOR 61 DAYS UNDER 24,000 MILES WHEN IT FAILED!
Mar 20, 2023
POWER TRAIN,SERVICE BRAKES
4 complaints
I am getting the Shift system error and error u200296 when I get it scanned. The shift linkage keeps popping off and we have replaced it multiple times making it impossible to change gears
Jun 01, 2023
Failure of vacuum pump caused the brakes and engine to fail on the highway. No warning indications appeared until after the vehicle was brought to a stop. The vehicle was diagnosed at Riser Ford. The mechanics claim that a plastic part in the vacuum pump system broke. After further research I found that this a common occurrence with the Eco boost engines. An investigation is warranted, Ford's negligence and poor build quality has become a safety concern.
Apr 11, 2023
The contact owns a 2017 Ford Fusion. The contact stated while the vehicle was parked in her driveway on a hill without the emergency brakes, the vehicle rolled down the hill and bumped into her husband's parked vehicle. The contact took the vehicle to a local dealer but was unable to duplicate the failure. The contact stated on April 2022, while she was driving at an unknown speed, the vehicle began to shake and failed to go over 50 mph. The contact stated no warning light was illuminated. The contact took the vehicle to a local dealer, where it was diagnosed with needing the transmission to be replaced. The vehicle was repaired. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 17V427000 (Power Train), however, the VIN was not included. The manufacturer had been informed of the failure and transferred her to the NHTSA Hotline. The failure mileage was approximately 72,000. The consumer stated she should be reimbursed for the repairs.
Jun 15, 2022
TL* THE CONTACT OWNS A 2017 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 35 MPH, THE BRAKE LIGHT ILLUMINATED CONTINUOUSLY. THE VEHICLE WAS TAKEN TO HERITAGE FORD 2100 SISK RD, MODESTO, CA 95350, FOR AN OIL CHANGE AND THE CONTACT INFORMED THE DEALER ABOUT THE FAILURE. THE DEALER INFORMED THE CONTACT BRAKE FLUID WAS PUT INTO THE VEHICLE IN ORDER TO REPAIR THE FAILURE. THE VEHICLE WAS REPAIR HOWEVER, A DAY LATER THE FAILURE RECURRED. THE CONTACT MENTIONED THAT A WHOLE CAN OF BRAKE FLUID WAS REPLENISHED IN THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY INFORMED THE CONTACT THE BRAKE LINE LEAKED FLUID DUE TO THE TRANSMISSION COMING INTO CONTACT WITH THE BRAKE LINES. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED A CASE NUMBER. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.
Feb 07, 2020
VISIBILITY/WIPER
4 complaints
IN HEAVY RAIN, THE HIGH SPEED OF THE WIPERS IS WAY TOO SLOW... MAKING IT UNSAFE TO SEE EVEN WHEN PRUDENCE OF SLOWING DOWN AND/OR POSSIBLY CONSIDERING PULLING OVER. ONE CANNOT SEE SAFELY ENOUGH TO SEEK A PULL OVER SPOT DURING THE IMMEDIACY OF THE SITUATION.. THUS ONGOING TRAVEL IS THE ONLY OPTION. WIPERS BLADES ARE GOOD. WINDSHIELD IS CLEAN. RAIN SHEETING / BLURRING OF VISION HAPPENS BECAUSE WIPERS AREN'T ABLE TO MOVE FAST ENOUGH
Jul 03, 2020
WINDSHIELD WIPERS CHATTER ACROSS WINDOW WHEN IT'S RAINING. THE CHATTER GETS SO BAD THAT THEY SKIP ACROSS THE WINDOW NOT CLEARING THE WINDOW COMPLETELY HITTING THE POST ON THE LEFT SIDE. THEN WHEN THEY ARE IN AN UPRIGHT POSITION THEY WILL STOP AND MAKE A LOUD SCRAPPING SOUND. THEY HAVE CHATTERED SO BAD THAT THEY HAVE ACTUALLY STOPED FUNCTIONING IN THE RAIN LEAVING NO VISIBILITY FOR DRIVING. THIS WAS ON THE FREEWAY CAUSING A DANGEROUS SITUATION. THE CAR HAS BEEN TAKEN INTO THE LOCAL FORD DEALERSHIP 4 TIMES. 1 TIME AFTER WE PURCHASED THE CAR, APPROXIMATELY 800 MILES, AND WE WERE TOLD THE WIPERS WERE JUST DIRTY. BETWEEN THIS VISIT AND THE NEXT 3 WE HAD TO PURCHASE REPLACEMENT WIPERS AT 6,000 MILES AS THE WIPERS WERE NOT PROPERLY CLEARING THE WINDOW, BUT THEY WERE ALSO CAUSING CHATTER. . HOWEVER, THE OLD WIPERS APPEARED BRAND NEW. DURING THE NEXT 3 VISITS TO THE LOCAL FORD DEALERSHIP IN EUREKA CA WE WERE TOLD NOTHING WAS WRONG, BUT THEY APPLIED RAINEX OR A SIMILAR PRODUCT. THE WINDOW WAS "CLEANED". LASTLY THE WINDSHIELD WIPERS WERE REPLACED. THEY ALSO APPEARED BRAND NEW. UPON TALKING TO THE SERVICE REP WE WERE TOLD THAT THE WIPERS ON OUR FORD FUSION WERE NOT PROPERLY DESIGNED FOR OUR FORD FUSION AND THEY WERE FACTORY WIPERS. HE ALSO STATED THAT SEVERAL OF THE SERVICE TECHS HAVE FUSIONS AND THEY HAVE HAD SIMILAR SITUATIONS. WE HAVE HAD THIS SET OF WIPERS ON FOR SEVERAL WEEKS AND ALREADY RUNNING INTO PROBLEMS. I SHOULDN'T BE AFRAID TO DRIVE MY CAR BECAUSE I REALLY LIKE IT. HOWEVER, I CAN'T JEOPARDIZE THE LIVES OF MY GRANDCHILDREN, OTHERS AND MYSELF. PLEASE HELP MISS MIMI
Mar 14, 2018
BOUNCE BACK WINDOW FEATURE CAN NOT BE DISABLED. EVERY TIME MY WIFE OPENS THE SIDE WINDOW, THE WINDOW WILL NOT CLOSE. THE WINDOW GOES TO THE TOP AND COMES BACK DOWN BY ITSELF. THE DEALER SAYS THIS IS NORMAL. THE DEALER REPROGRAMMED IT. THE NEXT TIME MY WIFE TOUCHED IT, IT FAILED. A SEARCH ON THE INTERNET GAVE A FEW THOUSAND INSTRUCTIONS ON HOW TO REPROGRAM IT. THIS IS A BIG SAFETY ISSUE. SHE LOWERED THE WINDOW ON THE INTERSTATE. THEN SHE TRIED TO CLOSE IT. IT WOULDN'T CLOSE. NOW SHE IS GOING 65 MPH AND FOOLING AROUND WITH THE WINDOW TRYING TO GET IT TO CLOSE. SHE SHOULD BE CONCENTRATING ON DRIVING, NOT FOOLING AROUND WITH A WINDOW. FURTHERMORE, IF SHE IS STOPPED IN TRAFFIC AND SEES SOME SEEDY INDIVIDUAL COMING NEAR HER SHE CAN'T CLOSE THE WINDOW.
Nov 28, 2017
WIPER SPRAY NOZZLES DO NOT SPRAY ON THE WINDSHIELD VERY WELL MAKING IT DIFFICULT TO CLEAR A DIRTY WINDSHIELD. THE WIPER ARMS BLOCK THE LEFT AND RIGHT SPRAYERS AND ONLY GET A SMALL AMOUNT OF FLUID ON THE WINDSHIELD. AFTER THE WIPERS LEAVE THE HOME POSITION AND STAY SLIGHTLY ELEVATED ON THE WINDSHIELD THE CENTER SPRAYER CAN NO LONGER SPRAY PAST IT TO COVER THE WINDSHIELD EITHER.
Nov 17, 2016
SERVICE BRAKES, HYDRAULIC,POWER TRAIN
3 complaints
The contact owns a 2017 Ford Fusion. The contact stated that after shifting to drive(D), the vehicle erroneously rolled backwards up a slight incline. The failure had occurred on several occasions. Additionally, while driving down a hill and depressing the brake pedal, the brakes malfunctioned, the vehicle failed to stop, and drove through a 4-Way intersection and drove approximately a half mile before stopping. During the failure, the message "Transmission not in Park" was displayed. The cause of the failure was not yet determined. The manufacturer and local dealer were not contacted regarding the failure. The failure mileage was 160,000.
Dec 16, 2025
The contact owns a 2017 Ford Fusion. The contact stated that the vehicle was stuck in gear while accelerating from a stop. The contact stated that the vehicle failed to move. The brake and ABS warning lights were illuminated. The vehicle was towed to an independent mechanic, who determined that the transmission bushing needed to be replaced. The vehicle was repaired, but the failure recurred. While reversing, the vehicle became stuck in the street. The contacts' son was able to maneuver the gears, and the vehicle started moving. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, opened a case, and referred the contact to the NHTSA Hotline. The failure mileage was approximately 97,000.
May 19, 2025
The contact owns a 2017 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) however, the part to do the recall repair was unavailable. The contact stated that while coming to a stop at a stop signal, the vehicle jerked forward. The contact stated that the failure recurred after shifting into reverse(R). The contact also stated that while his wife was driving at an undisclosed speed, the brake pedal was depressed but the vehicle failed to respond. No warning lights were illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the transmission needed to be replaced. The vehicle remained at the dealer awaiting the repair. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The approximate failure mileage was 105,000.
Apr 11, 2023
POWER TRAIN,UNKNOWN OR OTHER,ENGINE
3 complaints
Vehicle purchased used at Simmons & Rockwell on [XXX] Mileage 16,323. Mileage 38,559 First Engine Failure & replaced "NEW" July 2019, *** indications & doc of 2nd engine failure about 70k mileage) Mileage 121,163 Second Engine Failure & replaced "NEW" August 2022 and finally Mileage 189,323 with Third Engine Failure Sept 2025 This vehicle had regularly interval oil changes. ALWAYS Serviced & maintenaced regularly INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Oct 05, 2025
I have the 2.5 liter engine in my 2017 ford fusion but it’s also experiencing the same coolant leak symptoms of other engine models of this year of vehicle. Car has no visible leaks but coolant levels keep dropping. Temp gauge goes up and down back and forth. Car seems to be sputtering while driving. Currently just passed 100,000 miles this week. I’ve had the vehicle for 7 years and it seems like recall after recall.
Apr 14, 2024
The car started shaking while driving down the road and when coming to a stop. The gears were not shifting properly. I took it to a mechanic shop and they told me several different things "could" be wrong, supposedly fixed it, $700 for that. Started shaking and shift gear problems again, took it in again and spent $2800 for the supposed fix. Several days later same thing, took it back again and they said to take it to a transmission shop because they couldn't do anymore. Found out there was a recall on the torque and the different mechanic "fixed" that. Now it won't shift into several of the gears. Over $4500.00 spent! Transmission
Feb 15, 2024
UNKNOWN OR OTHER,ENGINE,FUEL/PROPULSION SYSTEM
3 complaints
Engine has cylinders flooding with coolant due to the design of the EcoBoost engine
Oct 02, 2025
The antifreeze leaks into the engine due to a KNOWN manufacturer design flaw, is available to inspection upon request and appointment made. Mine and others safety are at risk due to the fact that if the engine seizes up while driving, could lead to a sudden crash. Problem confirmed by a local mechanic. Not been inspected by anyone else other than a different independent mechanic. The first sign of a problem is a check engine light, followed by a sputter in the engine and lack of consistent speed control, first appeared in February, and lead to 2 sets of spark plugs being replaced
Jun 06, 2024
I went to my dealership because of a check engine light. After many hours of searching, I was told that a coolant leak had been found. I was informed that the head gasket was damaged and causing a leak into the engine. The cheapest repair would cost nearly $8000. The extended warranty that I purchased for the car has expired. Searching Google, I see that Ford is aware of the problem, and has known about it for some time. Ford should not be able to get away with this.
Jan 26, 2024
POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM
3 complaints
Just got my car I’m financing (used) It’s been giving me problems since I got it slow acceleration, overheat . , engine stalling Start and go Option isn’t working . Can I have a professional assist me with a recall maintenance please
Apr 18, 2025
THE OWNER/MYSELF DRIVING VEHICLE HOME MY 2017 FORD FUSION SE 1.5L ON THE INTERSTATE WHEN WHITE SMOKE BILLOWED OUT FROM THE EXHAUST LEADING TO A SEIZED ENGINE ON A HIGH TRAFFIC DENSITY HIGHWAY. THE CAR STARTED TO SPUTTER, CLUNK AND THE CHECK ENGINE LIGHT KEPT FLASHING AS I PULLED OFF THE SIDE OF THE ROAD. THIS CAR HAD ISSUES BEFORE THE FAILURE OF THE ENGINE WITH CYLINDERS MISFIRING, SPARK PLUGS BEING FOULED AT LOW MILEAGE AND ENGINE LOSING COOLANT. PER MY VEHICLES BREAKDOWN I BROUGHT IT TO A LOCAL MECHANIC WHO WORKED FOR FORD AND STATED MY ENGINE LOCKED UP AND NEEDS TO BE REPLACED, AFTER BRINGING MY CAR TO ANOTHER SHOP FOR A SECOND DIAGNOSIS, IT WAS THE SAME ANSWER AFTER A FULL LOOK AT IT. I TRIED CALLING FORD IN MICHIGAN THEY GAVE ME THE RUN AROUND, MY DEALER FRED BEANS OF FORD GAVE ME THE RUN AROUND SAYING I HAVE TO COVER THIS REPAIR DUE TO IT BEING OUT OF MY WARRANTY. I DID THE PROGRAM 19B37 RECALL FROM FORD WHICH RESET THE COMPUTER SYSTEM FOR ANTIFREEZE AND COOLANT ENTERING THE ENGINE. CLEARLY, THAT ISSUE THAT FORD TRIED TO PATCH UP DIDN'T WORK. MY MECHANIC & FORD DETERMINED THAT A NEW ENGINE WAS NEEDED AND HAVE FOUND BULLETINS STATING THIS IS DUE TO A MANUFACTURING DEFECT KNOWN BY FORD AS FORD HAD RELEASED THE BULLETINS. THIS DEFECT LEADS TO ENGINE FAILURE AND IS NOTHING CAUSED BY THE DRIVER BUT SOLELY DUE TO THE FACT THAT WHEN CERTAIN ENGINES WERE MANUFACTURED THEY WERE MANUFACTURED INCORRECTLY. FORD IS UNWILLING TO PAY FOR ENGINE REPLACEMENT EVEN THOUGH THEY HAVE ADMITTED THIS IS FAULT DURING THE MANUFACTURING PROCESSES IF THE ENGINE IS TO STALL OR SEIZE DURING DRIVING THIS COULD LEAD TO SERIOUS INJURY, ACCIDENT, AND EVEN DEATH. FORD IS NOT RECALLING THIS ENGINE AT THIS TIME. PLEASE - RECALL THIS ISSUE. 1.5 & 2.0 ENGINES ARE VERY PROBLEMATIC. THE COST FOR MY REPAIR IS $4,800.00 THAT I DON'T HAVE.
Dec 04, 2020
CAR STALLED AFTER ACCELERATING MODERATELY HARD INTO TRAFFIC FROM A STOP AND THEN QUICKLY TURNING LEFT INTO PARKING LOT.
May 01, 2020
POWER TRAIN,ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM
3 complaints
I believe my 2017 ford fusion should be included in the recall for the BECM for the 2019-2020 because my charging port has a sticker with QR code and ( CD391 PHEV ) and I keep having intermittent problems with the Battery Energy Control Module
Apr 12, 2025
BACK IN 2018, 1.3 MILLION FORD FOCUS VEHICLES WERE RECALLED DUE TO A FUEL PURGE VALVE. WHO'S TO SAY THE SAME ISSUE IS STARTING TO OCCUR AGAIN, BUT TO THE FORD FUSIONS? MY 2017 FORD FUSION THAT I PURCHASED 6 MONTHS AGO HAS THIS ISSUE. IT IS A MAJOR SAFETY CONCERN! ON MY WAY TO WORK IN THE MIDDLE OF THE HIGHWAY, DURING MORNING TRAFFIC, MY CAR DECIDES TO TURN OFF CAUSING A ACCIDENT, BUT LUCKILY NOBODY GOT HURT! WHILE I WAS SITTING THERE WAITING FOR THE POLICE TO ARRIVE, I TRIED TURNING IT BACK ON, AND LUCKILY IT DID, BUT SURPRISE SURPRISE NOW WITH THE SERVICE ENGINE LIGHT ON. WHEN I GOT OFF OF WORK MY CAR TURNED BACK ON (STILL WITH THE SERVICE ENGINE LIGHT ON) AND THE SAME ISSUE HAPPENED AGAIN 4 TIMES ON MY WAY BACK HOME. I DROVE ALL THE WAY BACK ON THE RIGHT HAND PASSING LANE BECAUSE THIS IS A SAFETY HAZARD, AND COULD EASILY CAUSE A ACCIDENT AGAIN! WHAT IT DID EXACTLY IS IT STARTS LIKE A HUMMING/VIBRATING NOISE THAT COMES FROM THE DASHBOARD, I COULDN'T PUSH ON MY GAS, TURN MY STEERING WHEEL, AND AUTOMATICALLY GOES DOWN TO 0 MPH, AND ON THE DASHBOARD IT ASKED ME TO PUT THE CAR IN P, AND THEN TURNS OFF. OF COURSE THE WARRANTY THAT I PURCHASED DIDN'T WANT TO COVER IT, AND NOW I HAVE TO PAY $425 TO HAVE THIS FIXED! FORD MOTOR COMPANY NEEDS TO ISSUE A RECALL BEFORE SOMEONE SERIOUSLY GETS INJURED!
Nov 12, 2020
IN MAY 2017 MY FORD FUSION SPORT LOST POWER TO THE WHEELS WHILE ACCELERATING, I WAS ABLE TO BRAKE AND COAST TO A STOP ON THE SIDE OF THE ROAD. TURNED VEHICLE OFF AND ISSUE WENT AWAY. TOOK CAR TO BOB RORHMAN DEALERSHIP IN SCHAUMBURG IL, FORD AND DEALERSHIP STATES NTF, NO TROUBLE FOUND, FORD CORPORATE SERVICE MANAGERS ALSO SAID NTF, CASE FILE 12313619-N2S9X3. ON AUGUST 7TH, 2018 THE ISSUE HAPPENED AGAIN AS I WAS LEAVING WORK, I ACCELERATED AND CAR WENT INTO LIMP MODE. I PROCEEDED TO THE SIDE OF THE ROAD AS I WAS GETTING HONKED AT BY OTHER DRIVERS, TURNED CAR OFF AND ON AND THE ISSUE WENT AWAY. I OPENED A NEW CASE FILE WITH FORD CAS15469320 ON 8/9/2018. THE ETB HAS BEEN AN ISSUE IN THE PAST, REFERENCE 'CUSTOMER SATISFACTION PROGRAM (13N03)'. I DEEM THIS A CRITICAL SAFETY CONCERN, IF I WAS A FORD ENGINEER ON MY FMEA THIS FAILURE MODE SEVERITY IS A 10, I WORK IN AUTOMOTIVE. I HAVE PHOTOS AND VIDEOS OF THE INCIDENT.
Aug 09, 2018
STRUCTURE
3 complaints
Trunk pops open on its own
Feb 11, 2025
The contact owns a 2017 Ford Fusion. The contact stated that while placing her grandchild in the car seat in the rear of the vehicle, she became aware of mold inside the vehicle. The contact stated that the rear passenger’s side and the trunk had mold. The contact stated that water had leaked into the vehicle from the overhead light. The contact stated she was constantly sick and had ear infections. The vehicle was taken to a dealer. The vehicle was inspected; however, the contact was unsure of the results. The dealer informed the contact that the failure was a known issue; however, the repair would be an out-of-pocket expense. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 60,000.
Aug 09, 2024
WHEN REENTERING THE CAR AFTER A GROCERY SHOPPING TRIP, THE REAR PASSENGER DOOR WOULD CLOSE BUT NOT LATCH. THE CATCH FOR THE LATCH MOVES FREELY BUT SEVERAL ATTEMPTS TO SECURE THE DOOR FAILED. MY HUSBAND TRIED SEVERAL TIMES TO SECURE THE DOOR SO WE COULD LEAVE THE PARKING LOT AND DRIVE HOME. ULTIMATELY, BECAUSE IT IS A HOT, SUNDAY AFTERNOON, HE OPTED TO SIT IN THE REAR PASSENGER SEAT AND MOVED OUR TEEN DAUGHTER TO THE FRONT SEAT SO HE COULD HOLD THE DOOR CLOSED ON OUR DRIVE HOME. WE MADE IT HOME WITHOUT INCIDENT AND HE TRIED SEVERAL MORE TIMES ONCE THE CAR WAS PARKED TO SECURE THE DOOR PROPERLY WITHOUT SUCCESS.
Jun 14, 2020
SERVICE BRAKES,ENGINE
3 complaints
The Ford Fusion suffered a brake and engine failure. Ford mechanics claim it is due to a plastic part in the vacuum pump. This vehicle is completely unsafe and is prone to mechanical failures that snowball into hazardous driving conditions.
Apr 06, 2023
Brake failure - major near miss accident on Sunday March 26, 2023.
Apr 05, 2023
WHILE DRIVING IN TRAFFIC NEWER STYLE VACUUM PUMP FAILED IN MY 2017 FORD FUSION ALMOST REAR ENDED A TRUCK WHILE DIDNT KNOW WHAT THE PROBLEM WAS TALKED TO A FEW FORD DEALERS THAT TOLD ME IT WOULD BE OVER A WEEK BEFORE I WOULD BE ABLE TO GET MY CAR SERVICED. SO I STARTED TO TEST MY MY PARTS GOT A P0012 AND P0014 CODE AND PINPOINTED A DESTROYED VACUUM PUMP THAT HAD NO SUCTION.BREAKS ASSISTANCE WAS LOST
Oct 04, 2019
POWER TRAIN,ELECTRICAL SYSTEM,ENGINE
3 complaints
PRIMARY CONCERN: CAR LOSES ALL PROPULSION AND GOES INTO ACCESORY MODE WHEN ACCELERATING. I, AS WELL AS SEVERAL OTHERS WITH 2017 FORD FUSION SPORT MODELS, HAVE LOST TOTAL POWER WHILE LEAVING RED LIGHTS, STOP SIGNS, AND WORST OF ALL, MERGING ONTO THE HIGHWAY. MY CAR DIED UNDER NORMAL ACCELERATION WHILE ATTEMPTING TO MERGE ON THE HIGHWAY, AND WHILE PULLING AWAY FROM A STOP SIGN, ON TWO DIFFERENT OCCASIONS, MONTHS APART FROM EACH OTHER. A MEMBER OF OUR FACEBOOK GROUP OF FUSION SPORT OWNERS CAPTURED HIS CAR LOSE ALL POWER, ON VIDEO, AND HIS CAR IS BEING BOUGHT BACK BY FORD, BUT THAT IS NOT ENOUGH. THESE CARS, ALTHOUGH FUN AND ENJOYABLE, POSE A SERIOUS THREAT TO NOT ONLY THE OWNERS OF THE CAR, BUT ALSO TO OTHER DRIVERS ON THE ROAD WHO COULD HIT US FROM BEHIND, INJURING OF KILLING PASSENGERS IN EITHER VEHICLE, OR VEHICLES NEARBY. THIS CAR NEEDS TO BE RECALLED AND REMOVED FROM THE ROAD. HERE IS HIS VIDEO: HTTPS://YOUTU.BE/NLNN0HKRHTG
Feb 01, 2019
DRIVING ON ROAD ROUGHLY 40 MPH AND VEHICLE COMPLETELY LOST POWER. CAR LOST POWER AND STARTED SLOWING DOWN. ERROR MESSAGE ON THE DASH "FULL ACCESSORY POWER ACTIVE:. NEEDED TO IMMEDIATELY PULL OFF TO THE RIGHT OF THE ROAD IN ORDER TO AVOID TRAFFIC. THIS IS A SERIOUS ISSUE.
Feb 14, 2018
MY CAR, WITH 2K MILES, WOULD NOT START (PUSH BUTTON START, THIS IS THE PLUG-IN HYBRID "ENERGI" MODEL). AFTER BEING TOWED TO A DEALER, THEY HAD TO TEAR THE CAR APART TO FIND A BAD WIRING HARNESS AS PART OF THE HYBRID SYSTEM. THIS PART WAS UNAVAILABLE, AND I AM HAVING TO WAIT OVER 5 DAYS TO HAVE THE CAR REPAIRED. IN ADDITION, THE MANUFACTURER HAS NOT PROVIDED ANY ALTERNATE TRANSPORTATION AND INSTEAD TRIED TO GET ME TO BUY AN EXTENDED WARRANTY. HORRIBLE CUSTOMER SUPPORT FROM FORD. THIS IS A SAFETY FIX, AND THE CAR ITSELF JUST WOULDN'T RUN. TO NOT TAKE CARE OF THE CUSTOMER OR HAVE THE ABILITY TO QUICKLY GET A PART IS UNACCEPTABLE. WIRING HARNESSES SHOULD NOT FAIL IN 5 WEEKS AND 2K MILES. THE CAR DROVE ONE MILE, THEN WOULD NOT RESTART. IT ONLY COMPLAINED TO "GET OFF THE ROAD SOON". A FAILURE OF WHAT SHOULD BE A VERY BASIC PART AT 2K MILES IS CONCERNING, NOT TO MENTION THE INABILITY OF FORD TO REPAIR IT IN QUICK FASHION. THIS DOES MAKE ME WONDER IF THE PROBLEM IS MORE WIDESPREAD AND SO PARTS ARE HARD TO COME BY.
Sep 09, 2016
ELECTRICAL SYSTEM,VISIBILITY/WIPER
3 complaints
WHILE TRYING TO USE AUTO IN WINDOWS THE WINDOW WOULD GO UP THEN RIGHT BACK DOWN SIS IT LIKE 17 TIMES BACK TO BACK. ALSO AFTER SHUTTING CAR OFF WHILE SITTING IN THE CAR IT PUSHED THE LOCK BUTTON AND RECEIVED A MESSAGE SAYING SOMETHING ABOUT SWITCHES
May 22, 2018
JUST AFTER LEAVING DEALERSHIP FOR THE CARS FIRST OIL CHANGE, THE CAR NO LONGER HAS BLINKERS, WIPERS (EXCEPT FAST SPEED) AND ALL STEERING WHEEL CONTROLS ARE INACTIVE.
Jan 22, 2018
ISSUE 1: FMVSS CRITICAL SAFETY ISSUE. INTERMITTENT TOTAL FAILURE OF CLIMATE CONTROL SYSTEM, INCLUDING FAILURE OF DEFOGGER CAUSING OBSTRUCTED VISIBILITY IN COLD CLIMATES (VEHICLE IS BASED IN METROPOLITAN DETROIT). THE FAILURE IS BOTH ELECTRICAL AND MECHANICAL. NEITHER THE TOUCH SCREEN NOR THE PHYSICAL CONSOLE BUTTONS RESPOND TO COMMANDS. AFTER SECOND INTERMITTENT FAILURE, THE VEHICLE WAS PARKED OVERNIGHT IN AN ATTACHED HOME GARAGE. AFTER IGNITION, DEFOGGER FUNCTIONED, BUT NO OTHER CLIMATE FUNCTIONS WORKED. DEFOGGER EMITTED A BURNING SMELL AKIN TO A CAMPFIRE. FORCED TO DRIVE WITH SUCH CONDITIONS TO WORK TO MAINTAIN VISIBILITY. ISSUE 2: POSSIBLE FMVSS SAFETY ISSUE. INTERMITTENT FAILURE OF THE AUDIO SYSTEM, INCLUDING SNYC COMMANDS. TOUCHSCREEN (BOTH ON THE HOME SCREEN AND ON THE TOOLBAR AT THE BOTTOM OF THE SCREEN) AND PHYSICAL BUTTONS DO NOT RESPOND WHEN AUDIO BUTTONS ARE PRESSED. WHEN THIS HAPPENS, SYNC DOES NOT RESPOND. ALTHOUGH BLUETOOTH IS ACTIVE, OCCUPANTS CANNOT HEAR THE DIALED PARTY, AND THE DIALED PARTY CANNOT HEAR THE OCCUPANTS. SINCE SYNC IS TIED INTO 911 SYSTEM FOR CRASHES, THIS WILL PREVENT OCCUPANTS FROM ENGAGING WITH 911 OPERATORS HANDS-FREE IN AN ACCIDENT. IF OCCUPANTS CANNOT REACH/MANIPULATE PHONE IN A CRASH, THEY MAY BE UNABLE TO CALL FOR HELP. ISSUE 3: INTERMITTENT REAR CAMERA FAILURE. AFTER RAINFALL AND FROST EVENTS, THE REAR CAMERA DOES NOT ENGAGE WHEN THE VEHICLE IS PLACED IN REVERSE GEAR. THE SCREEN IS BLACK, EXCEPT FOR AN OUTLINE OF THE VEHICLE. THE RADAR SENSORS REMAIN ACTIVE AND BEEPS IF THE VEHICLE IS CLOSE TO BACKING INTO AN OBJECT. AFTER A PERIOD OF DRYNESS, THE CAMERA RE-ENGAGES. I ASSUME THERE IS A MOISTURE INTRUSION PROBLEM, BUT AM UNABLE TO IDENTIFY THE ENTRY POINT. ONLINE SEARCHES SUGGEST THAT MOISTURE MAY BE INTRUDING THROUGH THE FACTORY-INSTALLED, ROOF-MOUNTED ANTENNA.
Jan 06, 2017
STEERING,ELECTRICAL SYSTEM
2 complaints
Car warning states “steering assist fault service required” total loss of power steering in the vehicle after sat parked for a week, vehicle started without issue, no warning codes can be found with OBDII scanner
Dec 29, 2025
I drove about 11 miles total to get on the interstate, when I was about 7-9miles into my drive, my steering wheel started to lock up. I slammed on my breaks, and kept twisting and turning my steering wheel for about 2 miles to the nearest gas station. I had tons of lights pop up on my dash and they said my steering system is failed. Something along those lines. It said something about my shifter being messed up as well? I have had 0 lights on, 0 warnings, nothing. If I was going any faster than I was I could’ve been seriously injured. I almost ran straight into a bridge before I slammed my breaks on to ensure I wouldn’t hurt myself or wreck the car. Not sure why my steering would just all-of-the-sudden go out? I haven’t had any problems previous to this situation so it’s very unsafe and honestly terrifying. This situation could’ve gone south really fast, if I would’ve been on the interstate it could’ve been fatal.
Jan 03, 2022
UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM
2 complaints
Have had to replace the same 2 coil pacs in last three months. Car will not accelerate properly will not shift into gears properly took to have information test done keeps coming back fouled 2 & 4 coils
Nov 07, 2025
EVAP system leak causes car to not start after putting gas in the car. Engine light stays on causing the key fob not to auto start the car. Loud Knocking noise coming from the gas tank.
Nov 21, 2024
POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE
2 complaints
2 separate dealerships made me pay to replace faulty tires when the new ones blew out within less than a month of purchase. They also pocketed the mail in rebates I was promised for buying new sets of tires from their locations. I started taking my car to an independent garage for regular maintenance. My traction control light has been on since shortly after I bought the car in 2018 but I never imagined I'd be spending my entire savings on repairs immediately after the useless warranty expired. First it was a cracked flex plate which I'm lucky happened when I was driving on a side road as opposed to the interstate. I was going roughly 55mph when I lost my ability to steer, accelerate, or even cut power to the ignition. My car has been towed 4 times with total cost of almost 10K and it still isn't fixed. I reported everything to Ford they don't stand by anything Ford manufactures. I'll probably be living in this piece of trash soon enough as that savings I just wasted was a down payment for a house
Oct 11, 2025
CAR WAS ACCELERATING ON THE HIGHWAY AT ABOUT 50 MPH AND OUT OF NO WHERE CAR SHIFTS VERY HARD AND ALL POWER IS LOST. HAD TO LIMP TO THE SIDE OF THE HIGHWAY AND SHUT IT OFF. THIS WAS VERY DANGEROUS. AFTER A RESTART IT SEEMED TO ACT FINE UNTIL TODAY WHEN THE SAME THING HAPPENED ON A LOCAL ROAD AT ABOUT 20 MPH.
Feb 20, 2018
ELECTRICAL SYSTEM,UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM
2 complaints
NHTSA COMPLAINT - 2017 Ford Fusion Energi Titanium (VIN: REDACTED) - [XXX] (Collision) Q1: FAILED COMPONENT Battery Energy Control Module (BECM) and hybrid battery cell balancing circuits failed post-collision. Per Ford Recall 23V-440, Current Interrupt Device causes excess voltage, fire risk, toxic gas exposure. DTCs: U1027 (ABS/ECM loss), P2450/P2451 (EVAP stuck open/closed), P0DD2/P0DD6/P0DDE (battery cell balancing circuits H/J/K/M stuck off). Vehicle available for inspection. Q2: SAFETY RISKS Sudden power loss, fire risk, CO/HF toxic gas exposure from damaged cells. HF IDLH 0.025 g/m³. Symptoms: headaches, cognitive issues, respiratory problems requiring Brain MRI. Ford documented 7 fires, 2 while driving. Gas events recur when changing charging amperage; CO detector alarmed repeatedly; hospitalized for symptoms. Q3: DEALER CONFIRMATION NOT investigated. No Ford dealer conducted required post-collision battery diagnostics despite DTCs proving multiple system failures. United Insurance Claims ignored [legal demand] for hybrid-specific inspections. No CO/HF assessment. Battery cell balancing failures indicate physical collision damage to high-voltage system. Q4: INSPECTIONS Insurance: Standard only, ignored DTCs requiring hybrid testing. Ford Service (Tempe, AZ) and Ford Collision Center (Mesa, AZ): No inspection; reasons given a) lack capability b) we just scan the vehicle; we don't thoroughly inspect for gas leaks". Recall 23V-440 documents identical failures. Police: No report (real-time audio capture of admission of at-fault driver), no hazmat assessment. Multiple permanent DTCs prove need for Ford-certified diagnostics. Q5: WARNING SYMPTOMS Pre-collision: Intermittent issues, check engine light, reduced range. Post-collision: Reduced range, Gas exposure symptoms plus DTCs U1027, P2450/P2451, P0DD2/P0DD6/P0DDE showing communication/battery cell failures. Medical documentation available. Pattern confirms BECM/battery damage per documented defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Sep 06, 2025
THE WINDOWS GO UP AND DOWN BY THEMSELVES AND YOU CAN'T PUT THEM UP ALL THE WAY OR THEY WILL GO BACK DOWN BY THEMSELVES AND THEIR IS SOME KIND OF INTERFERENCE IN THE ELECTRICAL SYSTEM THAT COMES THROUGH THE STEREO AND LIGHTS. AND THIS SAME PROBLEMS HAPPENED 2 TIME'S BEFORE THIS DATE BELOW SO IT HAPPENED 3 TIMES
Apr 20, 2019
VISIBILITY
2 complaints
The contact owns a 2017 Ford Fusion. The contact stated that while operating the vehicle and attempting to close the front passenger side window or the front driver's side window, the windows raised up but failed to remain closed. The contact stated that the windows immediately rolled back down independently. The cause of the failure was not yet determined, and the vehicle was not repaired. The local dealer and manufacturer were notified of the failure, but no assistance was provided. The contact was informed of a TSB related to the failure, but no assistance to repair the vehicle was offered. The failure mileage was 22,000.
Jul 08, 2025
The contact owns a 2017 Ford Fusion. The contact stated that while operating the vehicle, the front window defroster was inoperable causing a visibility hazard to the driver. Additionally, all the windows in the vehicle were inoperable and would not roll down. The cause of the failure was not yet determined. The local dealer was notified of the failure but no assistance was offered. The manufacturer was not yet contacted. The VIN was not available. The failure mileage was 92,000.
Apr 13, 2022
ENGINE AND ENGINE COOLING,POWER TRAIN
2 complaints
The contact owns a 2017 Ford Fusion. The contact stated while driving at an undisclosed speed, the power train fault message was displayed, and check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who determined that there was coolant intrusion into the cylinders, causing engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to the Customer Satisfaction Program: 21N12. The manufacturer was notified of the failure, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 55,352.
Apr 18, 2025
The contact owns a 2017 Ford Fusion. The contact stated that while driving at various speeds the vehicle would not properly accelerate. The vehicle was taken to the local mechanic who diagnosed that the transmission was faulty. The transmission was rebuilt and the failure was remedied. The vehicle later experienced engine failures causing the check engine light to illuminate, a slushing liquid sound was present inside the dashboard and the vehicle had experienced harsh driving. The vehicle was taken to the local dealer who diagnosed that the engine coolant was present inside the engine cylinders and the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure but no assistance was offered. The failure mileage was 78,000.
Jul 19, 2024
LATCHES/LOCKS/LINKAGES
2 complaints
The contact owns a 2017 Ford Fusion. The contact stated that the passenger’s side doors failed to open as intended. The contact stated that the door handle had detached from the door. There was no warning light illuminated. The contact stated that the door failed to open from the outside. The contact stated that the failure had occurred twice. The dealer was not contacted. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 87,419.
Apr 17, 2025
The contact owns a 2017 Ford Fusion. The contact stated while driving approximately 10 MPH, the trunk would inadvertently open whenever the temperature was over 80 degrees. The contact also stated the trunk would inadvertently open while shifting gears. There was a clicking sound coming from the instrument panel whenever the trunk would open independently. There was no warning light illuminated. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 35,000.
Jul 01, 2022
FUEL SYSTEM, GASOLINE,ENGINE
2 complaints
The contact owns a 2017 Ford Fusion. The contact stated that the check engine warning light was illuminated. The message to clean around the gas cap was displayed. The contact stated while driving 30 MPH, the vehicle made an abnormally loud sound and was vibrating. The contact pulled over to the side of the road. The contact noticed that the sound was coming from the fuel tank flap. The contact stated that while pushing the fuel tank flap, the contact felt a significant air pressure, and the failure ceased after the flap was closed; however, the failure recurred while the flap was not completely closed. Additionally, the contact stated that the vehicle was experiencing rough idling and the vehicle stalled while at a traffic light. The contact stated there was black smoke coming from the tailpipe. The vehicle was taken to Auto Zone, where it was diagnosed and determined that the EVAP system was leaking, and the EVAP canister control valve had failed and needed to be replaced. The dealer was notified of the failure. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 86,000.
Feb 25, 2025
The contact owns a 2017 Ford Fusion. The contact stated that the check engine warning light was illuminated. The warning light turned off after refueling the vehicle with fuel. The failure persisted and had gotten worse with the check engine warning light remaining illuminated. The vehicle was taken to a certified mechanic and the fuel pump was replaced. The check engine warning light remained illuminated. The vehicle was returned to the certified mechanic who stated that the fuel tank needed to be replaced. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 88,000.
Apr 17, 2023
ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM
2 complaints
There is a recall on 2017 Ford Fusion's torque converter. I currently have a 2017 Ford Fusion. After inspection at a Ford service dealership, the "torque converter clutch internally failed filling the transmission filter with metal debris and starving the pump for fluid causing debris to go throughout the transmission." The problem with this, is that even though it's list as a recall for ,y specific car, the recall is not listed under my VIN number. This inspection was done on December 17, 2024. The safety of myself and children were put at risk when my car hesitated to accelerate on multiple occurrences on busy roads and intersections. The problem has been reproduced by a Ford dealer and has also been inspected by a Ford service dealership. There were no warning lights on indicating that there was a problem.
Dec 31, 2024
Car dies and fuel tank honks all the time even while putting gas in it won’t start or will die it happens at red lights all the time I have a hard time grit to start back up it’s very dangerous
Jul 02, 2023
POWER TRAIN,VEHICLE SPEED CONTROL,FUEL/PROPULSION SYSTEM
2 complaints
Stopped at red light. When removing pedal from brake car would not move forward. Made revving noise when has applied. Car would not move but was still running. Could not drive car afterwards. .
Dec 17, 2024
I am having a lot of problems with my transmission and torque converter and after some research I’ve seen those are both commonly recalled parts on the 2017 ford fusion. My car only has 67,000 miles on it and I believe it’s too soon for this to be a problem. When I try to accelerate from 2nd to 3rd gear my tachometer shoots up and my car will start doing a jerking motion and won’t accelerate
Oct 28, 2024
ELECTRICAL SYSTEM,SERVICE BRAKES,ENGINE
2 complaints
Manufacturer Recall Number23S12 NHTSA Recall Number23V162 Recall on my vehicle Ford has failed to attempt remedy as of December 2023.
Feb 23, 2024
My car started smoking out of nowhere, smoke was coming out of the tail pipe. My cars check engine light begin to blink. The whole entire car begin to shake. It was making a rattling sound, the car begin to slow down on its own, even though I was pressing the gas. It wouldn’t go any faster than 65 miles an hour as the car begin to shake and make a loud rattling noise. My AC went out all of a sudden this was two hours after getting it serviced.
Jul 27, 2023
SERVICE BRAKES, AIR
2 complaints
The contact owns a 2017 Ford Fusion. The contact stated while driving at approximately 35 MPH, the ABS warning light illuminated and several other unknown warning lights flashed on and off. The contact had taken the vehicle to a parts seller who scanned the vehicle and found the following codes, U2002-96, C2008-92, and C2006-74. The vehicle had not been repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 105,000.
May 31, 2023
The contact owns a 2017 Ford Fusion. The contact stated while his wife was driving the vehicle, the brake pedal was depressed to the floorboard with the brake warning light illuminated on the instrument panel. Upon inspection of the vehicle, the contact discovered splattered brake fluid underneath the vehicle. The contact had the vehicle towed the dealer and was provided an estimate to replace both brake lines. The manufacturer was also notified of the failure and the contact was informed that there were no recalls on the vehicle and that the warranty did not cover the repair. The contact was then referred to the NHTSA for assistance. The vehicle was not repaired and remained in the possession of the dealer. The failure mileage was approximately 74,000.
Apr 29, 2022
POWER TRAIN,SERVICE BRAKES,ENGINE
2 complaints
The shifting was not working when making the selected gear and it was driving in an unintended direction when it was selected reversed. The car was driving forward when the operator selects was in reversed.
Apr 26, 2023
The shifting was not working when making the selected gear and it was driving in an unintended direction when it was selected reversed. The car was driving forward when the operation selects was in reversed. The car was accelerated by itself when I was driving the car and the dashboard did not gave me any warning light that something in the car need attention.
Apr 26, 2023
POWER TRAIN,VEHICLE SPEED CONTROL
2 complaints
TL* THE CONTACT OWNS A 2017 FORD FUSION. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 10-20 MPH, THE VEHICLE STARTED TO DECELERATE INDEPENDENTLY. THE CONTACT CHECKED AND VERIFIED THAT THE VEHICLE WAS IN THE PROPER GEAR. THE CONTACT STATED THAT THE VEHICLE FAILED TO ACCELERATE AND STOPPED INDEPENDENTLY. THE CONTACT TURNED OFF AND RESTARTED THE VEHICLE HOWEVER, THE GEAR SHIFTER FAILED TO SHIFT OUT OF PARK. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE SHIFTER LINK BUSHING NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT UNDER RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.
Apr 29, 2021
ON MAY 13, 2017 OR THERE ABOUT MY 2017 FORD FUSION FROM A STOPPED DURING TAKE OFF ACCELERATED VERY FAST ALMOST CAUSING ME TO RUN INTO THE REAR OF ANOTHER VEHICLE. ON MAY 15, 2017 I TOOK MY CAR IN FOR SERVICE AND TOLD TECHNICIAN ABOUT IT. HE COULD NOT FIND A PROBLEM. AGAIN ON SEPTEMBER 20, 2017 I TOOK MY CAR IN SPECIFICALLY TO HAVE THE ACCELERATION PROBLEM CHECKED OUT AND AGAIN NO PROBLEM WAS FOUND. I WAS TOLD TO BRING THE VEHICLE IN SOON AS IT HAPPENED. ON OCTOBER 10, 2017 TAKING OFF FROM A STATIONARY POSITION I TOOK OFF AFTER LIGHT TURNED GREEN AND THE CAR JUST TOOK OFF ACCELERATING IN A CURVE CAUSING ME TO LOOSE CONTROL AND I RAN INTO A TREE.
Oct 11, 2018
ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL
2 complaints
I WAS DRIVING AND PROCEEDED TO PARK AND I COULDN'T SHIFT FROM DRIVE TO PARK. IT HAPPENED TWICE SINCE THE 20TH OF MARCH. I HAD TO TURN OFF CAR AND SHIFT AGAIN. THE CAR SHIFTED AT THAT MOMENT. IT SEEMS THIS ISSUE IS 'COMMON' IN THE 2017 FORD FUSION AUTOMOBILES. THESE CARS SHOULD BE RECALLED TO SOLVE THIS ISSUE. THANK YOU FOR YOUR ASSISTANCE IN ADVANCE. IF YOU HAVE ANY QUESTIONS, PLEASE CALL ME AT [XXX] OR EMAIL [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Mar 23, 2021
I HAVE HAD MY BATTERY REPLACED A NUMBER OF TIMES MY CAR LOSES POWER OFTEN HAS TO BE JUMP STARTED. THE CRUISE CONTROL ACTIVATES ITSELF SPEEDING ME UP AND SLOWING ME DOWN AND THE RADIO NO LONGER WORKS ACTUALLY NONE OF THE CONTROLS ON THE STEERING WHEEL AND OR THE RADIO WORK
Mar 15, 2019
EXTERIOR LIGHTING
2 complaints
STANDARD FRONT LIGHTS ARE INSUFFICIENT TO SEE CLEARLY. DESIGN FLAW MAKES IT IMPOSSIBLE AND COSTLY TO BUY YOUR OWN BRIGHTER BULB(SULVANIABRIGHT WHITE)AND HAVE IT INSTALLED, COSTING UPWARDS OF $400. REMEDY; INSTRUCT FORD TO COVER THE COST OF INSULLATING INTERNAL IF CUSTOMER BUYS A BETTER BULB. AND REDUCE COST OF INTALLING
Nov 19, 2017
THIS IS NOT CONFINED TO FUSIONS, IT'S MOST NEW FORD CARS AND TRUCKS. THEIR HEADLIGHTS (LED?) ARE BLINDINGLY BRIGHT TO ONCOMING TRAFFIC. THE FUSION IN PARTICULAR CASTS VERY BRIGHT OUT TO THE LEFT SIDE AS TO BE DISTRACTING TO VEHICLES IN THE LANE TO THEIR LEFT TRAVELING IN THE SAME DIRECTION. I'VE OBSERVED THIS MOSTLY ON 2-LANE ROADS.
Apr 22, 2017
ELECTRICAL SYSTEM,FORWARD COLLISION AVOIDANCE
1 complaint
Leaking fluids
Oct 06, 2025
UNKNOWN OR OTHER,SERVICE BRAKES,ENGINE
1 complaint
I am a single mother raising my 6-year-old daughter on my own. This past year has been extremely difficult, as my car has been constantly in and out of repair shops. I have spent more than $8,000 in the last year and a half on unexpected repairs, many of them involving serious safety issues. I was never informed about the recall and never received any notice. This situation has caused me a lot of stress and hardship, and I am asking for guidance and support to help me through it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Sep 24, 2025
SERVICE BRAKES,FORWARD COLLISION AVOIDANCE
1 complaint
I had a bad car accident October 2019 going 45 mph, I push the breaks the car didn’t stop and I crashed not after a month from getting the car from drivetime on a special discount
Sep 05, 2025
POWER TRAIN,ENGINE,FORWARD COLLISION AVOIDANCE
1 complaint
The cylinder wall failed which led to coolant loss into the motor
Mar 02, 2025
ELECTRICAL SYSTEM,SEATS
1 complaint
I obtained my vehicle on Lease in 2017 with 40K miles from Ford of Branford CT. When off lease I purchased it outright. I still own the vehicle and am still having Two main problems, One since almost the beginning. The First is the automatic seat control(driver's). This system would periodically push the driver into the Steering Wheel. I brought it into that dealership several times for that reason, while still in CT. They did claim to get it to stop doing this with some resets, but over time it continued. Around 2020, the vehicle began going totally dead. Initially it was determined to be the Starting Battery. My concern was it to ba a Compiter or Power drain problem. Several batteries and Dealership visits didn't solve it. I moved to SC in May 2022. These problems continued there, where Cox Ford of Southern Pines took over. After more Service visits the only answer was a BAD BATTERY. Recently, after returning from Vacation and having to jump start the vehicle two times, I had several conversations with the service department. Finally a new Service writer found some information. A Technical Service Bulletin described how in this vehicle, how under seat wiring for the automatic seats, were becoming frayed and shorting on metal rails.(182025A). Also another for Battery Drain (SSM 50250). My Automotive background (which I no longer do) Tells me that electric seat wiring, grounding against seat rails could cause the Battery to be Draining. I believe they could be connected.
Jan 22, 2025
EXTERIOR LIGHTING,VEHICLE SPEED CONTROL,VISIBILITY/WIPER
1 complaint
Steering wheel clock spring is not working. Controls wipers, turn signals, speed control, voice commands, lane aware and allows to toggle thru control settings do not work. Ford doesn’t have part available or an ETA. This part covers vehicles from 2013 thru 2024 so currently vehicles coming down assembly line are using. My car is unusable like this. Aftermarket part is also unavailable. Please help
Oct 17, 2024
ELECTRICAL SYSTEM,EXTERIOR LIGHTING,SERVICE BRAKES
1 complaint
My brakes are faulty sometimes I’m not able to stop like I should. I also have transmission problems. When I put the car into reverse or drive I hear a loud boom. It is getting worse by the day. I see that the transmission is on a recall as well.
Aug 20, 2024
UNKNOWN OR OTHER,SERVICE BRAKES,FUEL/PROPULSION SYSTEM
1 complaint
My brakes are grinding squealing/rattling and i have pads replaced, no rotor wear, not sure what’s wrong. I’ve brought my car in to be serviced 3+ times and have left with no fixed car and worse brakes. When i bring up issues with my car that are related to the recalls the car has, they tell me those recalls don’t apply to my car although im having the same problems. My brakes have progressively gotten worse/louder and the pressure on my pedals is not the same. I’m scared to drive my car and i have been trying to get it fixed for months. This is not the only problem im having, my gas tank “farts” constantly and my car will stall and shut off unless i turn off auto start stop. There is no recall on this yet it’s a KNOWN problem. It makes the car undriveable.
May 21, 2024
SUSPENSION,POWER TRAIN
1 complaint
The contact owns a 2017 Ford Fusion. The contact stated that after shifting from park(P) into drive(D), the gear shifter erroneously shifted back to park(P). The vehicle was taken to the local dealer who diagnosed that the shifter cable bushing was faulty and needed to be replaced. The shifter cable bushing was replaced, and the vehicle was repaired; however, the failure reoccurred. Additionally, while operating the vehicle, the steering wheel abruptly jerked to the left. The vehicle was taken to the local dealer who determined that the front ball joints were faulty and needed to be replaced. No further information was available. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was provided. The approximate failure mileage was 100,000.
May 09, 2024
SERVICE BRAKES, HYDRAULIC,ELECTRONIC STABILITY CONTROL (ESC),ENGINE AND ENGINE COOLING
1 complaint
The contact owns a 2017 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic). The contact stated that while driving at an undisclosed speed, the electronic stability control (ESC) and check engine warning lights illuminated. The vehicle was taken to the dealer for the recall repair, and it was determined that rodents had chewed the soy-based ESC wiring harness. The contact was informed that the ESC wiring harness and purge solenoid valve needed to be replaced. The contact was also informed that the engine needed to be cleaned due to rodent droppings and that mothballs needed to be placed beneath the hood to deter rodents from entering the vehicle. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 138,546.
May 01, 2024
STEERING,TRACTION CONTROL SYSTEM
1 complaint
The contact's daughter owns a 2017 Ford Fusion. The contact stated that while his daughter was driving at approximately 45 MPH, the vehicle lost power steering functionality. The contact stated that the power steering assist, traction control, and hill stop assist warning lights were illuminated. The vehicle was taken to a dealer where it was diagnosed that the rack and pinion needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 86,720.
Feb 27, 2024
ENGINE AND ENGINE COOLING,EQUIPMENT
1 complaint
The contact owns a 2017 Ford Fusion. The contact stated that while the vehicle was idling at a red light, the vehicle lost motive power and shut off. After several minutes the vehicle restarted, and the contact was able to continue driving. The contact stated that coolant was leaking underneath the front end of the vehicle, and there was white smoke coming from the exhaust during the initial startup. The coolant level was low. The check engine warning light was illuminated. The contact believed that the failure was related to NHTSA ID Number: 10210392 (Engine and Engine Cooling, Equipment). The vehicle was taken to an auto body shop to be diagnosed. The contact was informed of a misfire in cylinder #2. The contact's father had changed the spark plugs. The vehicle was then taken to the dealer and the contact was informed that the air intake was missing from the vehicle. The contact was informed that the air intake needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure, and it was confirmed that VIN was included in the NHTSA ID Number: 10210392 (Engine and Engine Cooling, Equipment) however, it was no longer covered due to exceeding the mileage indicated in the TSB. The contact was referred to the NHTSA Hotline. The failure mileage was 86,683.
Jan 19, 2024
ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,ENGINE
1 complaint
Turbocharger leaked oil into the engine causing irreparable damage to the engine. Oil leaking cause engine failure, smoke coming out of the tailpipe, several blown gaskets and steering wheel malfunction. Cars computer system froze, enabling vehicle to move forward. Motor mounts were faulty, loose and unstable. Grinding sounds coming from wheels, vehicle alignment is unsteady. Issues with this vehicle previously reported under NHTSA ID #11534780 updated information being reported after repairs have been repaired.
Sep 19, 2023
ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,FUEL/PROPULSION SYSTEM
1 complaint
1). 3 days after purchasing the vehicle I wasn't sure but I could tell that something was wrong so I called my husband and told him while driving the car that something was wrong and he needs to notify the dealership. 2). 5 days after purchasing the vehicle I went into a grocery store. When I came out the car was on/running, all by itself. 3). Additional problems occurring on a daily basis with the vehicle which lets me know that it's electrical problems are as follows: A. The vehicle randomly turns on and off all by itself, this is very hazardous. B). The headlights also randomly do not work while driving the car, day or night, which is very hazardous for both me and my clientele, as I am a Lyft driver. C). The interior lighting on the console and dashboard become dim or do not turn on at all, day or night. D). While driving the vehicle it does not always accelerate properly, which is very hazardous in traffic. E). The Bluetooth system connects and disconnects itself randomly. F). The air and heating system randomly turn on and off without being touched. G). Charging my phone in the vehicle is also challenging as it does not always work. H). Bluetooth radio stereo system is continuously problematic, volume randomly increases and decreases and turns on and off by itself, even with the vehicle completely shut down. I). After locking the doors, everything inside the car does not completely turn off. Interior lighting sometimes turns off and on separately, and it can take up to 30 minutes for the dashboard lighting to go off. J). The instrument panel often makes some sort of sound/noise and the gear shifter dial will aluminate even though the car is off/completely shut down. K). While driving, front windshield defogger will randomly turns on, causing the windshield to fog up, distorting vision, which is very hazardous. L). Dashboard vents emit an extreme amount of heat even though both heater and air conditioner are completely off.
Sep 18, 2023
SERVICE BRAKES, HYDRAULIC,SERVICE BRAKES
1 complaint
The contact owns a 2017 Ford Fusion. The contact stated while driving approximately 20–30 MPH, the brake pedal was depressed, but there was resistance, and the brakes was slow to respond. While driving approximately 50 MPH, the brake pedal was firm and had to be pumped several times to respond. The contact stated that the brake hose had ruptured. The brake fluid warning light was illuminated. The contact was able to get the vehicle off the road. The vehicle was towed to the local dealer and the contact was informed that there was brake fluid on the brake pads and the brake pads needed to be replaced. The vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic). However, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 58,000. Parts distribution disconnect.
Sep 08, 2023
ENGINE,ELECTRICAL SYSTEM
1 complaint
The contact owns a 2017 Ford Focus. The contact stated while reversing from a the driveway, the vehicle was sputtering as if the cylinders had misfired. When the vehicle was shifted into drive, there was slow acceleration. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that spark plugs misfire in cylinder 2. The independent mechanic advised the contact to go to the dealer because it was an engine issue. The vehicle was driven to the dealer where it was diagnosed that a spark plug misfire in cylinder 2. The vehicle was not repaired due to a fee. The manufacturer was made aware of the failure but offered no assistance. The contact was informed that the vehicle was no longer under Warranty. The failure mileage was 98,500.
Aug 10, 2023
POWER TRAIN,ELECTRICAL SYSTEM,SERVICE BRAKES
1 complaint
Due to transmission issues from what in hearing. The cars front end locked up while i was driving. I could not push the car out of the steeet. It is stuck in park. Luckily I wasn't on the freeway. But I was on a busy street and the police had to block the road.
Jul 19, 2023
STEERING,VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE
1 complaint
ACCIDENT
Jun 12, 2023
SERVICE BRAKES, HYDRAULIC,ENGINE
1 complaint
The contact owns a 2017 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed, and the brake pedal was spongy. The brake pedal went to the floorboard. The check engine warning light was illuminated. The vehicle was towed to the dealer; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and confirmed that parts were not yet available. The failure mileage was approximately 82,000. VIN tool confirms parts not available.
May 09, 2023
SERVICE BRAKES, HYDRAULIC,POWER TRAIN,ELECTRICAL SYSTEM
1 complaint
The contact owns a 2017 Ford Fusion. The contact stated that while the vehicle was parked, the vehicle failed to start. Additionally, while driving at an undisclosed speed, the transmission shifted out of gear unintendedly. The contact stated that the passenger's and driver's side windows failed to operate as needed. The contact also noticed excessive fluid underneath the vehicle. The contact related the failure to NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic). The vehicle was taken to the dealer, who performed unknown repairs to the vehicle; however, the failure recurred. The manufacturer was made aware of the failure. The failure mileage was unknown.
Apr 26, 2023
SERVICE BRAKES, AIR,ELECTRICAL SYSTEM,ENGINE
1 complaint
The contact owns a 2017 Ford Fusion. The contact stated that the vehicle failed to start and required to be jumpstarted. The contact stated that the failure occurred intermittently. The contact stated while driving at various speeds, the vehicle stalled inadvertently. The contact stated that the failure mostly occurred while coming to a complete stop. The contact stated that on some occasions, the ABS warning light would illuminate and the ABS would make abnormal sounds prior to the failure; on other occasions, the check engine warning light was illuminated and a message indicating that the vehicle was overheating was displayed. The contact stated that the vehicle was towed three times out of the five to a Cadillac dealer and a Ford dealer. The dealers replaced the water pump, the alternator and an unknown part; however, the failure persisted. Additionally, the contact stated that the vehicle would lose electrical power while the battery was fully charged. The vehicle was not repaired. The contact later received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) that he related to the failure. The manufacturer was not notified of the failure. The failure mileage was approximately 80,000.
Apr 25, 2023
SERVICE BRAKES, HYDRAULIC,AIR BAGS
1 complaint
The contact owned a 2017 Ford Fusion. The contact stated that while driving at approximately 45 MPH, he depressed the brake pedal to make a right turn when the vehicle failed to respond. The contact applied pressure to the brake pedal and pumped the brake pedal several times to slow the vehicle with no success. As a result, the vehicle skipped a bridge and then crashed into a building. The air bags failed to deploy. The contact sustained bruising to the chest that required medical attention. A police report was filed. The vehicle was towed to a tow lot and deemed a total loss by the insurance company. The contact then received notification of the NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic). The dealer nor the manufacturer was not notified of the failure. The failure mileage was approximately 84,000.
Apr 19, 2023
SERVICE BRAKES, HYDRAULIC,TRACTION CONTROL SYSTEM,ELECTRICAL SYSTEM
1 complaint
The contact owns a 2017 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving approximately 15 MPH, she heard an abnormal clicking noise as she depressed the brake pedal. The contact stated that the vehicle kept moving forward. The contact started pumping the brake and suddenly the vehicle lost power steering assist and became very stiff. The contact stated that the brakes, traction control, and Hill Start Assist warning lights were illuminated. The contact let the vehicle coast to a stop and turned the vehicle off and on and the power steering returned. The contact stated that the brake failure had become constant. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the failure was related to NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) and parts were not yet available. The vehicle had not been repaired. The manufacturer had not been informed of the failure. The failure mileage was 142,245.
Apr 19, 2023
ELECTRICAL SYSTEM,SERVICE BRAKES
1 complaint
The contact owns a 2016 Ford Fusion. The contact stated that while depressing the brake pedal; brake fluid was seen leaking from underneath the front passenger’s side wheel. Additionally, the vehicle would not immediately start while pressing the brake pedal and START/STOP button. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure. The failure mileage was 138,000.
Apr 17, 2023
WHEELS,UNKNOWN OR OTHER,SERVICE BRAKES
1 complaint
Upon trying to stop at a stop sign my son was unable to stop in time and rolled into the roadway which caused a collision with another vehicle. He depressed the brakes and clearly heard a grinding noise and never felt the pumping feeling under his foot for the antilock breaks. He thought he couldnt stop due to ice on the roadway, but have since seen the brake recall on my vehicle. The accident caused the vehicle to become a total loss. The witnesses said my son stopped at the stop sing and pulled into the roadway in front of car going 50mph. That could not have happened by the angle of the car at the time of the accident. Had he stopped like the 'witnesses" said, he would have entered the roadway a couple second later and then become t-boned by the other car. He was hit on the rear quarterfinal coinciding with my sons story he could not stop. My son has held to his story that he tried to stop and the car would not stop. I have felt on occasion since Dec my brakes feeling a little off at times but never on a consistant basis to get it looked at. My vehicle had a small leakage in Dec which we could not locate and it never occurred since. We checked the brake fluid and all fluids routinely since. Never seen the leak since. I also put four brand new tires on my vehicle two days prior to the accident. It does appear in the photos after the accident there were new parts on the wheel in the area of the brakes. I only owned this vehicle for 9 months prior to this incident.
Mar 18, 2023
VEHICLE SPEED CONTROL
1 complaint
My Motor vehicle shift selector bushing broken out the ford issue is also in the 2017 models
Dec 25, 2022
SEATS
1 complaint
Seat back broke in a collision.
Dec 02, 2022
TRACTION CONTROL SYSTEM
1 complaint
The contact owns a 2017 Ford Escape. The contact stated that while driving at various speeds, the headlights became dim. The sunroof, Auto Start/Stop feature and traction control became inoperable. The contact stated that the check engine and traction control warning lights were illuminated. Additionally, coolant was leaking from the vehicle. The contact was able to add additional coolant to the vehicle. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted. The failure mileage was approximately 72,000.
Nov 22, 2022
ELECTRICAL SYSTEM,STRUCTURE,UNKNOWN OR OTHER
1 complaint
Trunk keeps popping open on its own while driving. Has happened at ranging speeds between 5 and 60 mph, different hours throughout the day, Temps between 27 and 70 degrees F. The Key fob is in clear site, on its own no one holding or any chance of button being pressed. Has also happened while in park, car not running. Came outside and it's open, also no chance of key fob being pressed. Happens multiple times per day. Removed all objects from truck, nothing on inside pressing or near safety release or blocking latch. Duplicated with different drivers and passengers present.
Oct 18, 2022
ENGINE,UNKNOWN OR OTHER
1 complaint
Engine dash light keeps coming on. A mechanic check engine number and printed TSB19-2346: 2.0L EcoBoost Ana says it’s under recall. But Ford dealerships around me refuse to do anything about it it. The error message is saying 2nd cylinder miss fire. Coolant keeps going low and car started to shut itself down.
Jul 08, 2022
SUSPENSION,UNKNOWN OR OTHER,ENGINE
1 complaint
Shift linkage keep detaching from the the transmission causing the transmission too slip. It detaches often it’s been going on for 2 months now. I called Ford dealership to see have they heard of this problem and they answer was no. It might be a recall on this vehicle.
Jun 14, 2021
POWER TRAIN,FORWARD COLLISION AVOIDANCE
1 complaint
WHILE TRYING TO REVERSE OR GO INTO DRIVE, MY SHIFT CABLE CAME OFF DUE TO A CAP BEING MISSING ON IT. THE ERROR 'SHIFT SYSTEM FAULT' KEEPS POPPING UP. AND NOW IT HAS EFFECTED MY TRANSMISSION TO THE POINT WHERE MY VEHICLE HAS ISSUES WITH ACCELERATING.
Jan 25, 2021
STEERING,SUSPENSION,WHEELS
1 complaint
TURNING INTO MY NEIGHBORHOOD AT ABOUT 10-15 MPH THE LEFT WHEEL AND HUB FELL OFF CAUSING THE CAR TO CRASH INTO THE PAVEMENT. THIS CAUSED ALOT OF DAMAGE TO THE FRONT BUMPER AND FENDERS. AND THE LINKAGE TO THE RIGHT WHEEL. FORD SAID IT WAS BECAUSE I HIT SOMETHING BUT I DID NOT HIT ANYTHING AND MY CAR STOPPED DEAD IN THE MIDDLE OF THE ROAD.
Jan 21, 2021
ELECTRICAL SYSTEM,AIR BAGS
1 complaint
TL* THE CONTACT OWNS A 2017 FORD FUSION. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE, THE SERVICE RESTRAINTS SYSTEM WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO METRO FORD SALES INC (3601 STATE ST, SCHENECTADY, NY 12304, (518) 868-6157) WHERE IT WAS DIAGNOSED AND DETERMINED THAT THE SERVICE RESTRAINTS MODULE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.
Jan 07, 2021
POWER TRAIN,ELECTRICAL SYSTEM,UNKNOWN OR OTHER
1 complaint
SHIFT DIAL GET STUCK IN PARK, WILL NOT SHIFT OUT OF PARK EVEN WITH THE OVERRIDE, HAVE HAD IT LOOKED AT TWICE, BOTH TIMES THERE WAS "NO PROBLEMS," AND THE SHOP ALWAYS IT WORKS WHEN THE TOW TRUCK DROPS IT OFF. IT HAPPENS ON AND OFF, NEVER GIVES AN ERROR MESSAGE OR THROWS A CODE. COULD BE DRIVING ONE MINUTE, GET HOME, SHUT THE CAR OFF, A COUPLE HOURS LATER GET BACK IN, AND IT DOESN'T SHIFT ANYMORE. IT'S EXTREMELY INCONVENIENT AND CONSIDERING THE FORD DEALERSHIP SAYS "THIS HAPPENS A LOT" I DON'T UNDERSTAND WHY THEY DON'T RECALL THE FAULTY CABLE OR RELAY OR TRANSMISSION OR SHIFT DIAL IF IT HAPPENS ALL THE TIME, BECAUSE AFTER TAKING IT TO 3 DIFFERENT SHOPS, THEY ALL HAVE NO ANSWER TO THE ISSUE, JUST TO "DEAL WITH IT". AND THE FACT THAT THE OVERRIDE DOESN'T WORK IS A BIG PROBLEM. BUT FORD DOES THEIR THING AND I GUESS WON'T RECALL SOMETHING THEY KNOW IS A PROBLEM ON MANY OF THEIR 2017 FORD FUSION SE'S EVEN THOUGH IT'S A SAFETY ISSUE BUT I GUESS THAT'S FORD, MORE ABOUT PUMPING CRAP CARS OUT THAN THEY ARE WORRIED ABOUT MAKING THEM SAFE WHEN THE SAME PROBLEM OCCURS ON MULTIPLE 2017 FORD FUSIONS.
Sep 27, 2020
ELECTRICAL SYSTEM,ELECTRONIC STABILITY CONTROL (ESC),ENGINE
1 complaint
VEHICLE CODES STARTED TO APPEAR ON THE DASHBOARD ( TEMP LIGHT, ENGINE LIGHT, BATTERY LIGHT) WARNING SIGNS ALSO APPEARED ( OVERHEATING IN ENGINE ) ENGINE COOLANT STARTED TO DECREASE NO LEAK WAS DETECTED. IT WAS TAKEN TO A MECHANIC TO GET EVALUATED AND THEY CAME TO THE CONCLUSION THAT IT WAS LEAKING INTERNALLY INTO THE CAR WHICH CAUSED OTHER ISSUES. THIS CAR WAS PURCHASED FEBRUARY 2020 SO 8 MONTHS LATER THE CAR HAS COMPLETELY CRASHED. WHITE SMOKE IS ALSO EXPELLING FROM THE VEHICLE EXHAUST. THE SPARK PLUGS ARE BURNING UP THEY WERE REPLACED APPROXIMATELY 8 DAYS AGO AND THEY ARE COMPLETELY BURNED WHITE.
Sep 24, 2020
STEERING,UNKNOWN OR OTHER
1 complaint
I WAS DRIVING HOME ONE NIGHT ON GORDON DR IN RUSTON, LOUISIANA WHEN AN ANIMAL ENTERED THE ROAD SO I STEERED TO THE LEFT TO AVOID THE ANIMAL AND SUDDENLY LOSS CONTROL OF STEERING. THIS CAUSED ME TO CRASH INTO A DITCH WITH A CEMENT DRAIN. MY CAR PROCEEDED TO DRAG ON THE GROUND SO I DID NOT DRIVE IT AND REPORTED IT TO INSURANCE AND IT WAS DECLARED TOTALED.
Sep 17, 2020
VEHICLE SPEED CONTROL,FUEL/PROPULSION SYSTEM
1 complaint
MY 2017 FORD FUSION WAS GOING TO DEALER FOR ITS 75,000 SERVICE AND TO UPDATE THE SOFTWARE WHICH WAS INCLUDED IN THE RECALL. I TOLD THEM ENGINE LIGHT HAD JUST COME ON .. THEY DIAGNOSED IT AS COOLANT IN THE ENGINE AND IT HAD RUINED THE ENGINE $6200 TO FIX IT I HAVE REPEATEDLY CALLED FORD FOR ASSISTANCE FOR THE DAMAGE RELATED TO THIS RECALL AND NOW THEY TELL ME THEY CANNOT HELP ME OUT .. IT IS MY PROBLEM THIS IS A THREE YEAR OLD CAR THAT I WISH I HAD NOT HAD FIXED AS I WAS CONFIDENT THAT FORD BEING THE GOOD OLD AMERICAN COMPANY THAT IT IS WOULD DO THE RIGHT THING AND BE TRUTHFUL AND STAND UP AND HELP ME OUT WITH A PROBLEM THAT IS CLEARLY THEIRS PLEASE HELP ME OUT I CANNOT AFFORD THIS AND IT'S PLAIN WRONG AND UNFAIR THAT I AS A LAW ABIDING CITIZEN HAS TO COVER THIS MISTAKE BY FORD T
Sep 02, 2020
ELECTRICAL SYSTEM,ELECTRONIC STABILITY CONTROL (ESC),FUEL/PROPULSION SYSTEM
1 complaint
CAR KEPT GIVING US A FLAT CODE FOR GEARS....SAYING TRANSMISSION WASNT IN PARK.CAR WOULDNT START OR SHIFT GEARS...THIS HAPPENED AS WE WERE DRIVING THE CAR
Jul 11, 2020
VEHICLE SPEED CONTROL,ENGINE,FUEL/PROPULSION SYSTEM
1 complaint
CAR BEGAN LOSING POWER UPHILL, AND EVEN PUSHING THE GAS PEDAL TO THE FLOOR DID NOT HELP. HIGH PRESSURE FUEL PUMP WAS REPLACED AT A FORD DEALERSHIP, BUT THE PROBLEM CONTINUED, AND GOT WORSE. EVENTUALLY HAD TO BE TOWED TO ANOTHER DEALERSHIP, WHERE THEY FIXED THE PROBLEM ENOUGH TO GET HOME, ALTHOUGH HILLS REMAINED AN ISSUE (CRUISE CONTROL WAS SET TO 70, AND EVEN THE SMALLEST HILL WOULD CAUSE THE CAR TO SLOW TO AROUND 40-45 MPH). CAR CURRENTLY IS SITTING IN MY DRIVEWAY BECAUSE I AM AFRAID TO DRIVE IT. IT MIGHT STALL OUT IN TRAFFIC.
Jul 07, 2020
AIR BAGS,ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES
1 complaint
SERVICE ADVANCED TRACK NOT WORKING STATIONARY. *TR
Jun 24, 2020
ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM
1 complaint
DIFFICULT TO START AFTER REFUELING (UNAFFECTED BY AMOUNT OF FUEL INSIDE TANK); INTERMITTENTLY GRUNTING/VIBRATION SOUNDS COMING FROM FUEL TANK AT RANDOM INTERVALS. HAPPENS WHILE PARKED AND WHILE IN MOTION. CAR HAS ALSO HAD ELECTRICAL-TYPE HUMMING SOUND COMING FROM GEAR KNOB AND DASH SINCE I BOUGHT IT WITH 36K MILES ON IT. *TR
May 30, 2020
WHEELS,UNKNOWN OR OTHER,ELECTRONIC STABILITY CONTROL (ESC)
1 complaint
WHEN DRIVING THE VEHICLE, AND THERE IS A BUMP RIGHT TIRE SEEMS TO SHAKE, WHEN TURNING TO THE RIGHT I HEAR A SCRAPE. WHEN THE VEHICLE IS ON AND ON PARKING, A RATTLING NOISE GOES OFF.
May 01, 2020
AIR BAGS,SEAT BELTS
1 complaint
TL* THE CONTACT OWNS A 2017 FORD FUSION. WHILE DRIVING APPROXIMATELY 70 MPH, THE DRIVER LOST CONTROL OF THE VEHICLE AND CRASHED INTO A CEMENT STRUCTURE. DURING THE CRASH, THE VEHICLE SUSTAINED DAMAGE TO THE FRONT DRIVER'S SIDE. THE AIR BAGS DID NOT DEPLOY. ALSO, THE DRIVER'S SIDE SEAT BELT LOCKING MECHANISM BECAME JAMMED AND THE DRIVER COULD NOT IMMEDIATELY EXIT THE VEHICLE. THE VEHICLE WAS TOWED FROM THE SCENE. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE CAUSE OF THE FAILURES WAS NOT DETERMINED. LIBERTY FORD BRUNSWICK (3101 CENTER RD, BRUNSWICK, OH) WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 40,000.
Nov 27, 2019
ELECTRICAL SYSTEM,SERVICE BRAKES,FUEL/PROPULSION SYSTEM
1 complaint
BRAKE ARE NOT WORKING
Oct 13, 2019
ELECTRICAL SYSTEM,EXTERIOR LIGHTING,SEATS
1 complaint
ERROR MESSAGE ON INSTRUMENT PANEL DISPLAYS "TEMPORARILY LOST COMMUNICATION WITH THE CLIMATE SYSTEM" WHEN THIS HAPPENS THE CLIMATE SYSTEM, RADIO, WINDOWS, AND SEAT CONTROLS STOP WORKING, THIS HAPPENS RANDOMLY AND CAN LAST AS LONG AS A WEEK. MANY OWNERS WITH SEVERAL DIFFERENT FORD MODELS ARE EXPERIENCING THIS PROBLEM AND FORD REFUSES TO ACKNOWLEDGE IT.
Oct 10, 2019
ELECTRICAL SYSTEM,SEATS,UNKNOWN OR OTHER
1 complaint
THE FORD "SYNC 3" SYSTEM, WHICH SEEMS TO BE THE BRAINS OF NEARLY ALL INTERIOR CONTROLS AND ACCESSORIES HAS BEEN MALFUNCTIONING IN MULTIPLE FORD MODELS FOR A FEW YEARS NOW. THING AFFECTED INCLUDE ALL HVAC CONTROLS, AUDIO CONTROLS, POWER SEATS, WINDOWS, REMOTE START ABILITIES AND MORE. FORD AWARE OF THE MALFUNCTIONS IN CURRENT AND PREVIOUS MODELS, YET THEY REFUSE TO ISSUE ANY RECALL OR TECHNICAL SERVICE BULLETIN. THE DEALERSHIPS INSIST THEY CAN'T DUPLICATE THE ISSUE EVEN AFTER HAVING BEEN SHOWN VIDEOS OF THE CARS MALFUNCTIONS. A QUICK SEARCH THROUGH ONLINE FORD FORUMS WILL THIS ISSUE IS WIDELY EXPERIENCED AND THAT IT'S CLEARLY A MANUFACTURING DEFECT AND FORD SHOULD BE LIABLE.
Sep 11, 2019
STRUCTURE,UNKNOWN OR OTHER
1 complaint
DRIVING ON THE HIGHWAY AT LEAST AT 65 MPH, THE CAR IN FRONT OF ME HIT HIS BRAKES AND WENT IN TO A COMPLETE STOP. I DID NOT HAVE TIME TO STOP, I HIT THE CAR, NONE OF THE AIR BAGS DEPLOYED. THE DRIVER SIDE DOOR COULD NOT OPEN BECAUSE THE FRAME OF THE CAR SHIFTED. RIGHT AFTER IMPACT A GUSH OF LIQUID STARTED POURING OUT. IT WAS TAKEN TO THE SHOP TO GET FIXED BUT AFTER A COUPLE OF DAYS THE CAR WAS DEEMED A TOTAL LOSS.
Aug 17, 2019
SUSPENSION,POWER TRAIN,ENGINE
1 complaint
I HAVE THE 2017 FUSION SPORT 2.7L TWIN TURBO AND I PURCHASED IT NEW. ON MORE THAN 30 OCCASIONS AND AT DIFFERENT SPEEDS THE VEHICLE LOSES ALL POWER WITHOUT WARNING. I HAVE HAD IT TO 2 DIFFERENT DEALERS WHO SAID THERE ARE NO CODES STORED INDICATING THIS HAPPENED AND SINCE THEY WEREN'T ABLE TO REPRODUCE THE ISSUE THAT THERE WAS NOTHING THEY COULD DO TO HELP. I FILED A COMPLAINT WITH FORD CORPORATE BUT THEY CLOSED MY CLAIM SINCE THEY HAD NO INDICATION THIS WAS OCCURING. I HAVE SEEN SEVERAL COMPLAINTS ABOUT THIS EXACT ISSUE BUT YET THEY CONTINUE TO DENY THE PROBLEM. ON A FEW OCCASIONS I WAS ON THE HIGHWAY RUNNING 70 MILES AN HOUR. HOW MANY PEOPLE HAVE TO DIE FOR THIS TO BE ACKNOWLEDGED? THE NHSTA NEEDS TO MAKE FORD STEP UP AND TAKE CARE OF THE PROBLEM. EVERY TIME THIS HAS HAPPENED THE CAR ALSO PUT ITSELF IN PARK BEFORE CAR WAS AT A COMPLETE STOP WHICH CAUSED A HARD JOLT TO THE TRANSMISSION. THIS IS GOING TO DAMAGE THE TRANSMISSION AMONG OTHER THINGS OVER TIME. I PAID $40,000 FOR THIS CAR AND DESERVE TO FEEL SAFE WHILE DRIVING IT ON THE ROAD. WHAT IF THIS WAS HAPPENING TO YOUR FAMILY WOULD YOU JUST IGNORE IT AND MAKE YOUR FAMILY KEEP DRIVING THE VEHICLE KNOWING AT ANYTIME IT COULD LOSE POWER AND CAUSE YOU TO WRECK? HOW COME NOTHING IS BEING DONE ABOUT THIS? MAKE THEM BUY MY CAR OR FIX THE ISSUE SO I DON'T HAVE TO PUT MY LIFE IN DANGER IN ORDER TO GET WORK. I AM A NURSE I SHOULD BE ABLE TO FEEL SAFE DRIVING TO WORK. THIS HAS NOT HAPPENED ONE TIME BUT WE'LL OVER 25-40 TIMES SINCE PURCHASE.
Aug 16, 2019
ELECTRICAL SYSTEM,EXTERIOR LIGHTING,VISIBILITY/WIPER
1 complaint
DRIVING CAR ONE DAY AND TURN SIGNALS FAILED TO FUNCTION WHEN PREPARING TO MAKE A TURN IN TOWN. CHECKED FUSES AND BULBS AND ALL WERE GOOD. TRIED THE LEFT TURN SIGNAL AND IT WAS NOT WORKING EITHER. ALSO NOTICED WIPERS AND NONE OF THE STEERING WHEEL CONTROLS WERE OPERATIONAL.
Jul 11, 2019
ELECTRICAL SYSTEM,VISIBILITY,VISIBILITY/WIPER
1 complaint
TL* THE CONTACT OWNS A 2017 FORD FUSION. THE CONTACT STATED THAT THE VEHICLE'S WINDOWS AND THE CLIMATE CONTROL FEATURE BECAME INOPERABLE. AS A RESULT, DURING INCLEMENT WEATHER, THE WINDOWS AND WINDSHIELD COULD NOT BE DEFOGGED, WHICH MADE IT DIFFICULT FOR THE CONTACT TO DRIVE. IN ADDITION, THE TMP FAULT WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 60,446.
Jun 11, 2018
STEERING,WHEELS,ELECTRONIC STABILITY CONTROL (ESC)
1 complaint
I WAS DRIVING THROUGH SAN JUAN CAPISTRANO CALIFORNIA EVENING OF JAN 3RD 2018 WEST BOUND ON HWY 74 HAVING JUST PAST THE OVERPASS ON I-5. I WAS ONLY GOING ABOUT 30 MPH AND THE STEERING SUDDENLY STOPPED WORKING AND MY CAR FLOATED OVER AND I COULD NOT STOP IT OR STEER. IT WAS THE STRANGEST THING I EVER EXPERIENCED. I FELT THE SENSORS IN THE CAR SUCK IN. MY CAR BOUNCED OVER THE CURB AND THE RIGHT FRONT WHEEL WAS TORN OFF IT. THE INSURANCE COMPANY TOTALED MY CAR OUT AND THE LOSS OF MY CAR HAS BEEN SIGNIFICANT LOSS OF INCOME AND ABILITY TO WORK TOO. I LOST SO MUCH OVER THIS CAR BEING TOTALED. I HAS USAA AUTO INSURANCE AND GAP COVERAGE ON THE NOTE. HOWEVER I HAD NO IDEA ABOUT HOW INSURANCE AND THE ABILITY TO RESTORE INSURANCE WOULD BE AFFECTED. I HAVE HAD TO SEE THIS AS AN AT FAULT ACCIDENT AND IT RAISED MY INSURANCE AND IMPACTS ME NEGATIVELY IN MANY WAYS FINANCIALLY. AIRBAGS DID NOT DEPLOY I ATTACHED LOSS DOCS, I HAVE PICS OF CAR AS WELL AS WHEEL WELL WHERE WHEEL WAS PULLED OFF AFTER BOUNCING OVER THE HIGH CURB.
May 24, 2018
ELECTRICAL SYSTEM,EXTERIOR LIGHTING,UNKNOWN OR OTHER
1 complaint
MY CAR WINDOWS WILL GO UP AND THEN AUTOMATIC COME BACK DOWN. THE RADIO SWITCHS CHANNELS ON ITS OWN. THE CAR STALLS OUT AND WON'T START. THIS HAS HAPPEN AND GOTTEN REPAIRED MORE THAN 6 TIMES IN THE LAST 1.5 YEARS. IT HAS HAPPENED AGAIN THIS PASS WEEKEND. MY LOCAL FORD DEALERSHIP IS GOING TO FIX AGAIN. AS OF NOW I AM PAYING FOR A CAR THAT FORD KEEPS SAYING DOES NOT FIT UNDER THE MARYLAND LEMON LAW. THIS CAR CLEARLY HAS SOME SERIOUS ELECTRICAL ISSUES THAT FORD DOES NOT EVEN UNDERSTAND. I AM PUTTING THE LATEST DATE ON IT, BUT IT HAS HAPPEN MULTIPLE TIMES IN THE LAST YEAR AND A HALF. THESE PROBLEMS OCCUR WHILE DRIVING OR STOPPED AT A LIGHT OR PARKED.
May 08, 2018
STEERING,ELECTRONIC STABILITY CONTROL (ESC),VISIBILITY/WIPER
1 complaint
STEERING TURNS EXCESSIVELY WITH TURN WHILE DRIVING, AND THEN STICKS. FORD STATES "ITS WORKING AS IT SHOULD". REPEATEDLY TAKES ME INTO ADJACENT LANE UPON LANE CHANGE, AND ALMOST OFF ROAD, WHEN GETTING OFF EXITS. WIPERS AND WINDSHIELD WIPER FLUID SYSTEM: 98% OF THE TIME, DOES NOT CLEAN THE TOP 1/3 OF DRIVERS VIEW OF WINDSHIELD. VISABILITY IS BETTER WHEN NOT USING OR MINIMIZING WIPER USE, IN RAIN, SNOW. SUSPENSION: DEATH RATTLE. VEHICLE INTERMITTENTLY EXCESSIVELY VIBRATES SO SEVERELY, AT ANY SPEED. WITH UNEVEN ROADS, AND HOLES, VEHICLES EXCESSIVELY RATTLES AND JUMPS SIDEWAYS IN LANE. THREE SIDEWALL FLAT TIRES IN LESS THAN ONE YEAR, THE FIRST YEAR OF OWNERSHIP.
May 08, 2018
AIR BAGS,STRUCTURE
1 complaint
TL* THE CONTACT OWNS A 2017 FORD FUSION. THE CONTACT STATED THAT THE HEADLINER FELL OUT OF PLACE IN THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER (MID VALLEY FORD DEALER LOCATED AT 201 NE POLK SATION RD, DALLAS, OR) AND THE HEADLINER WAS REPLACED BUT THE FAILURE RECURRED. THE VEHICLE WAS RETURNED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SIDE CURTAIN AIR BAG WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE AIR BAG WAS REPLACED, BUT THE FAILURE RECURRED. THE VEHICLE WAS RETURNED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE MOUNTING BRACKETS WERE WELDED INTO THE WRONG POSITION IN THE VEHICLE. THE ROOF OF THE VEHICLE WOULD HAVE TO BE DETACHED AND RE-WELDED INTO THE CORRECT POSITION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 32,000.
Dec 21, 2017
ELECTRONIC STABILITY CONTROL (ESC)
1 complaint
CAR WOULDN'T START AFTER SITTING IN THE DRIVEWAY WAY FOR 2 STRAIGHT DAYS. HAD IT TOWED TO DEALER AND AFTER CHECKING THE VEHICLE OUT, WAS TOLD I HAD A SEVERE ANT PROBLEM AND THE ANTS ATE THE WIRING IN THE FUSECOND BOX. HAD TO REPLACE FUSE BOX OUT OF POCKET BECAUSE I TOLD IT WAS NOT UNDER WARRANTY. I PURCHASED MY VEHICLE FEB 2017. PICKED UP MY VEHICLE AFTER REPAIRS AND A FEW MILES DOWN THE ROAD WHILE SITTING AT A RED LIGHT, MY VEHICLE SHUT DOWN WITH NO WARNING. NUMEROUS ERROR LIGHTS WERE ON, BUT COULDN'T RESTART THE CAR OR PUT INTO GEAR. AFTER 15-20 MINUTES I WAS ABLE TO START THE CAR AND MOVE IT OFF THE STREET. HAD IT TOWED BACK TO DEALER. DEALER DETERMINED THE BATTERY CABLE WAS STRIPPED AND HAD IT FIXED . ASSURED ME THE PROBLEM WAS RESOLVED. WEEK LATER WHILE DRIVING, CAR SHUT DOWN WITH NO WARNING. STEERING LOCKED, BRAKES NOT WORKING. WAS ABLE TO GLIDE INTO A PARKING LOT. TRIED TO START CAR AND WOULDN'T START. DEALERSHIP WAS CLOSED SO HAD TO GET IT TOWED TO MY RESIDENCE. NEXT DAY HAD IT TOWED TO DEALERSHIP. WHEN TOW TRUCK DRIVER TRIED TO START THE CAR IT STARTED WITH NO PROBLEM. VEHICLE IS SITTING AT DEALERSHIP TO BD LOOKED AT. FIRST TOW, I HAD TO PAY FOR REPAIRS OUT OF POCKET AND FOR THE RENTAL. SECOND TOW I WAS NOT CHARGED FOR DAMAGE TO THE BATTERY FROM THE FIRST REPAIR. THIRD TOW, I HAD TO ARGUE WITH THE DEALERSHIP TO PAY FOR THE RENTAL. STILL WAITING ON DETERMINATION OF PROBLEM. FIRST TIME VEHICLE WAS PARKED IN DRIVEWAY. SECOND AND THIRD TIME I WAS DRIVING AND ON A CITY STREET
Nov 25, 2017
STEERING,SUSPENSION,POWER TRAIN,WHEELS
1 complaint
TL* THE CONTACT OWNS A 2017 FORD FUSION. WHILE DRIVING 60 MPH, THE VEHICLE PULLED TO THE LEFT AND SWAYED. THERE WERE NO WARNING INDICATORS ILLUMINATED. BEFORE MAKING AN APPOINTMENT WITH SHEEHY FORD OF MARLOW HEIGHTS (5000 AUTH RD, MARLOW HEIGHTS, MD 20746 (301) 423-4950), THE VEHICLE STARTED PULLING TO THE RIGHT. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TIRES NEEDED AIR. ANOTHER TECHNICIAN DIAGNOSED THE VEHICLE AND REVEALED THAT THE FRONT CAMBER AND REAR TOE FAILED. THE REPAIRS NEEDED WERE UNKNOWN AND THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS ALSO TAKEN FOR A TEST DRIVE, BUT THE FAILURE WAS UNABLE TO BE DUPLICATED. THE MANUFACTURER WAS NOTIFIED AND INFORMED THE CONTACT TO MAKE AN APPOINTMENT WITH THE LOCAL DEALER. THE CONTACT STATED THAT THE GEAR SHIFT ALSO STARTED TO SHIFT INADVERTENTLY FROM DRIVE TO NEUTRAL. THE VEHICLE WAS TAKEN BACK TO SHEEHY FORD OF MARLOW, BUT THE FAILURE COULD NOT BE DUPLICATED. THE MANUFACTURER WAS NOTIFIED ONCE AGAIN AND INFORMED THE CONTACT TO MAKE AN APPOINTMENT. ON NOVEMBER 1, 2017, WHILE DRIVING 25 MPH, THE VEHICLE SHIFTED TO THE RIGHT, STRUCK TWO OTHER VEHICLES, FLIPPED OVER, AND LANDED ON ITS ROOF. ALL OF THE AIR BAGS DEPLOYED. THE CONTACT SUSTAINED BRUISES ALL OVER THE BODY AND INJURIES TO THE NECK, BACK, LEFT HIP, BOTH SHOULDERS, AND BOTH KNEES. THE CONTACT WAS TRANSPORTED BY AMBULANCE TO A LOCAL HOSPITAL. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A TOW LOT AND WAS AWAITING INSPECTION FROM THE INSURANCE COMPANY. THE MANUFACTURER WAS NOTIFIED AND A CASE WAS OPENED. THE INITIAL FAILURE MILEAGE WAS APPROXIMATELY 15 AND THE CRASH OCCURRED AT APPROXIMATELY 3,200 MILES.
Nov 09, 2017
ELECTRICAL SYSTEM,ELECTRONIC STABILITY CONTROL (ESC)
1 complaint
AT 1884 MILES, VEHICLE WOULD NOT START. WHEN JUMP STARTED, CHECK ENGINE LIGHT WAS ON. RETRIEVED CODES FOR "ALMOST EVERY MODULE" HAD LOW VOLTAGE. BATTERY WAS CHARGED AND CODES WERE CLEARED. SERVICE TECH SAYS THERE ARE NO SERVICE MEMOS OR RECALLS. IT APPEARS 14 COMPLAINTS OF DEAD BATTERY ON THIS MAKE/MODEL WERE FILED ON CARCOMPLAINTS.COM: HTTPS://WWW.CARCOMPLAINTS.COM/FORD/FUSION/2017/ELECTRICAL/DEAD_BATTERY.SHTML
Jul 25, 2017
EXTERIOR LIGHTING,VISIBILITY/WIPER
1 complaint
TL* THE CONTACT OWNS A 2017 FORD FUSION. WHILE DRIVING AT DUSK OR DAWN, THE HEADLAMP BEAMS WERE TOO DIM TO PROJECT A VISIBLE LIGHT TO SAFELY OPERATE THE VEHICLE. THE DEALER DIAGNOSED THAT THE HEADLAMPS OPERATED AS INTENDED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 100. THE VIN WAS NOT AVAILABLE. UPDATED 05/10/17*LJ *CN
Feb 15, 2017
STEERING,SERVICE BRAKES,ENGINE
1 complaint
WAS DRIVING IN A PARKING LOT, BETWEEN 5-10 MPH WHEN THE CAR CLICKED LOUDLY. I LOST STEERING AND BRAKES, AND CAME TO A SUDDEN STOP. THE ENGINE HAD TURNED OFF, THE CAR HAD PUT ITSELF INTO PARK, AND THE INSTRUMENT PANEL WENT BACK AS IF I HAD OPENED THE DOOR WITH THE CAR SHUT OFF.
Feb 06, 2017
Where to Find VIN for Problems Check
To check for problems and complaints on your 2017 FORD Fusion, you'll need the VIN number. Find your VIN in one of these 4 common locations.
Understanding VIN Structure for Problem Reports
Each character in your 2017 FORD Fusion 17-digit VIN helps identify specific complaints and problems affecting your vehicle model.
How to Check 2017 FORD Fusion Problems in 3 Steps
1
Locate Your VIN
Find the 17-character VIN on your 2017 FORD Fusion dashboard (visible through windshield), door jamb, engine bay, or vehicle documents.
2
Review by Component
Browse owner-reported complaints organized by vehicle component (engine, transmission, brakes, electrical) to identify common issues and problem patterns for this model year.
3
Check Safety Issues
Review crash and fire incidents for each component to assess safety concerns. Contact your FORD dealer or report problems to NHTSA at SaferCar.gov.
Frequently Asked Questions
How many problems does the 2017 FORD Fusion have?
The 2017 FORD Fusion currently has 1059 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.
What are the most common problems with 2017 FORD Fusion?
The most common problems reported for the 2017 FORD Fusion are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.
Where does this 2017 FORD Fusion problem data come from?
All problem and complaint data for the 2017 FORD Fusion comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.
How do I report problems with my 2017 FORD Fusion?
You can report safety problems with your 2017 FORD Fusion directly to NHTSA at SaferCar.gov or call 1-888-327-4236. Your complaint helps identify patterns and may lead to recalls or investigations.
Where can I find my VIN to check problems?
Your 2017 FORD Fusion VIN is located in 4 places: (1) Dashboard near windshield on driver's side, (2) Driver's door jamb sticker, (3) Engine bay, (4) Vehicle registration and insurance documents.
Is the 2017 FORD Fusion reliable?
Reliability can be assessed by reviewing the number and severity of owner complaints for the 2017 FORD Fusion. Check complaints by component, crash reports, and fire incidents above to evaluate potential issues and problem patterns.
Other Years - FORD Fusion Problems
Other FORD Models
'34
1500 Foldaway
A8513
A9513
A9522
Aerostar
Affordable Aluminum
Affordable Trailers
Aspire
AT8513
AT9513
AT9522
Similar Brands
ST
3,555 models
RS
3,484 models
NC
2,822 models
ND
2,385 models
Z
1,951 models
MOTO
1,583 models
NU
1,189 models
RC
1,122 models