2018 FORD Fusion Problems & Complaints
Real owner complaints and problems reported to the National Highway Traffic Safety Administration (NHTSA). View common issues by component.
VIN Decoder
397
Complaints Reported
As an Amazon Associate, ForCar.org earns from qualifying purchases.
Complaints by Component
ENGINE
103 complaints
Engine replaced due to flaw in design. I had my 60,000-mile service done and after it was completed, I started having serious issues with my vehicle. Kept getting check engine light cylinder 2 misfire. I took my Fusion back to the dealership, and they advised me that my engine had to be replaced. Apparently when they put my vehicle under pressure during the service it caused the coolant to leak into my engine. I have researched this and found many complaints with the same problem. Unfortunately, the owners of the other Fusions (like me) found out their vehicle was no longer under warranty, and they had to foot the entire bill. Luckly for me, I had purchased the Ford Extended Warranty, and my out-pocket pocket is $100. I was told by the dealership that Ford is aware of this issue but has not issued a recall. My service advisor was absolutely shocked when Ford authorized the necessary repairs in a couple hours berceuse it normally takes a few days to get authorization. I have owned this car since it was new and have always kept up with the required maintenance. They gave me a rental vehicle and said it would be about 7 days before the repairs are completed.
Oct 16, 2025
Coolant is leaking into the cylinders and causing overheating and no start.
Sep 11, 2025
The contact owns a 2018 Ford Fusion. The contact stated that while driving out of the driveway at 5 MPH, the engine light illuminated. The contact stated that the vehicle was difficult to start. The contact stated that the failure was like Customer Satisfaction Program: 21N12. The vehicle was taken to the local dealer for an oil change, and unknown engine repairs were completed. The vehicle was repaired, but the failure recurred. The vehicle was taken back to the local dealer, and it was determined that the engine needed to be replaced. The vehicle was not repaired. The dealer referred the contact to the manufacturer for assistance. The manufacturer was contacted and the referred the contact to the NHTSA Hotline. The manufacturer declined financial assistance, and stated that the issue would be escalated to the negative feedback department. The failure mileage was approximately 69,000.
Aug 01, 2025
My Vehicle was found to have a coolant intrusion. There is a know defect on these vehicles (1.5 / 2L) Ford engine. There was a hairline crack in 2 of the cylinders, which causes coolant to leak thoroughout the engine. My safety was put at risk as this issue causes the vehicles engine to overheat at an unsafe rate. 2 separate dealers found this issue CBA and Autonation Ford. Fidelity Warranty Services inspected the vehicle to see what would be covered. they appeared about 2 weeks prior but would disappear. It finally came back but was extremely repetitive
Jul 30, 2025
Engine light came on got it diagnosed said it was misfiring in cylinder 2. spark plugs and coil needed to be changed. Changed all spark plugs and coil and the engine light is still on and saying the same thing. Doesn’t crank right. Coolant going into engine. My vehicle only has 32,000 miles. Seems to be a know problem but ford will not do anything. Saying I need a new motor.
Jul 29, 2025
+ 98 more complaints for this component
ENGINE AND ENGINE COOLING
62 complaints
The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle started shuddering violently, hesitated, and failed to accelerate to approximately 35 MPH. The check engine warning light was flashing. The contact related the failure to the Customer Satisfaction Program: 21N12. The vehicle was towed to the local dealer, where it was diagnosed with coolant intrusion into the cylinders. The dealer informed the contact that the engine small block needed to be replaced, but a full engine replacement was recommended. The vehicle was not repaired. The manufacturer was contacted and filed a complaint. The manufacturer advised the contact that a future report would be issued. The failure mileage was approximately 100,000.
Nov 25, 2025
The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle was running rough, jerking, and shaking. The transmission and coolant temperature warning lights were illuminated. The message "Engine Overheating - Reduced Power" was displayed, and the vehicle went into LIMP Mode. The contact pulled over and had the vehicle towed to the residence. The vehicle was later towed to an independent mechanic, who determined that there was coolant intrusion in the engine, a blown head gasket, and a cracked engine block. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 148,000.
Oct 28, 2025
The contact owns a 2018 Ford Fusion. The contact stated that upon starting the vehicle, there was an abnormal rattling sound coming from the engine with white smoke coming from the exhaust system, with the check engine warning light illuminated. Additionally, the message “Service Vehicle Soon” was displayed. The vehicle was taken to a local dealer, where it was diagnosed, and the contact was informed that the engine was faulty due to coolant intrusion. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 84,112.
Sep 16, 2025
The contact owns a 2018 Ford Fusion. The contact stated that after the engine was replaced, there was an abnormally loud banging sound coming from the engine compartment. The vehicle was taken back to the local dealer, who diagnosed the vehicle with a cracked engine flex plate. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 59,851.
Aug 08, 2025
The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle briefly began to shake violently before returning to normal functionality. The check engine warning light was illuminated. The vehicle was taken to the dealer, who determined that coolant intrusion into various cylinders had resulted in damages to the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 130,000.
Jul 29, 2025
+ 57 more complaints for this component
POWER TRAIN
60 complaints
CVT transmission completely failed at 150k miles and is not covered by Ford
Jan 07, 2026
Car started running rough then white smoke was coming out the exhaust. Took it in to have it checked out by Ford and they said it was coolant intrusion into the cylinders. Now they want $9,000 to replace an engine that has less than 60,000 miles. I see online that this is not new and definitely a design flaw with this engine and many others.
Oct 28, 2025
Coolant intrusive. New motor needed
Aug 02, 2025
Shifter cable bushing degraded and fell off. Causing a condition where the car could not be shifted into or out of gear, and car applied park brake as a safety precaution and could not be disabled until the shifter was manually put back into park by mechanic. This bushing has been under recall for other year fusions but has not been extended to this one. Research on forums shows this is a very common problem. Could be a real safety issue if car cannot be shifted and it needs to be driven away in an emergency. This part should not fail in this short of time, it is made of inferior materials and does not last. No warnings given prior, part fails catastrophically.
Jul 31, 2025
The contact owns a 2018 Ford Fusion. The contact stated that after starting the vehicle, the gear shifter could not immediately be shifted out of park(P). The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was unknown.
Jul 17, 2025
+ 55 more complaints for this component
POWER TRAIN,ENGINE
17 complaints
What component or system failed or malfunctioned, and is it available for inspection upon request? The engine experienced coolant intrusion, which is a known defect in certain Ford EcoBoost engines. My independent mechanic diagnosed the issue after I noticed significant engine performance problems. The affected components, including the engine block and cooling system, are available for inspection upon request. How was your safety or the safety of others put at risk? Coolant intrusion can lead to engine overheating, misfires, and in severe cases, engine fires. This significantly increased the risk to my safety and that of others on the road. Had I not addressed the issue promptly, a fire could have occurred while driving. Has the problem been reproduced or confirmed by a dealer or independent service center? The problem was confirmed by an independent, certified mechanic—not by a Ford dealership. The dealer failed to properly diagnose or even acknowledge the problem, which appears to be common based on other consumer complaints. Ford did not identify what was truly going on with the vehicle, despite clear symptoms. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Ford has not inspected the vehicle. The manufacturer was notified, but they declined to take responsibility or offer a solution. There was no inspection by police or insurance representatives, as the issue was caught before a fire or accident occurred. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes. The engine began running rough and hesitating under acceleration. I also noticed excessive white smoke from the exhaust, and the check engine light came on intermittently. These symptoms began appearing several weeks before the full diagnosis, and Ford service failed to address them accurately during prior visits
May 01, 2025
The check engine light came on and something about the cooling system. I can’t totally remember. The Service desk confirmed the eco boost engine has known issues of the cooling system which may cause the engine to go bad. Reported I needed a new engine and transmission. Then after they had started that job and after I put $1,500 down they called me back and said the radiator has issues from it all and needed changed as well. I asked him if all fords only lasted approximately a 100,000 miles or just this one and he responded that it is a known issue by ford and happens with this engine. It cost me approximately $15,000 out of pocket to get the car fixed. Within a week there were more “issues” with the engine and I am now being charged over $300.00 to fix this part that they didn’t change even though they put in a new engine.
Apr 22, 2025
The contact owns a 2018 Ford Fusion. The contact stated that while starting the vehicle, the check engine warning light illuminated, and the "WRENCH" symbol was displayed. The contact was unable to shift the transmission into drive(D). The contact had to wait for approximately 15 to 20 minutes before attempting to restart the vehicle before shifting into drive(D). The contact stated that the failure recurred, and the vehicle was towed to the dealer. The dealer was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 95,000.
Mar 10, 2025
At 135,815 miles, my 2018 Ford Fusion SE experienced a sudden transmission failure while driving, with no prior warning signs. The vehicle was towed to Certified Transmission, where technicians confirmed: Transmission fluid level was correct but black/degraded. Multiple failure codes were present. Transmission pump whined and stopped functioning. Diagnosis: Internal transmission failure (6/17/2024). The shop stated this issue is common in these transmissions. The entire transmission had to be replaced. At 141,164 miles, just 5,349 miles later, the engine shut off on the highway while driving, again with no warning lights. After pulling onto the shoulder, it restarted after 10 minutes but was smoking heavily. Coolant was critically low in the reserve tank. Diagnosis: Cracked cylinder head due to coolant intrusion, a known defect in 1.5L EcoBoost engines. I contacted Ford Customer Care about CSP 21N12, but they refused assistance since my vehicle exceeds 84,000 miles, despite this well-documented defect. Safety Concerns: Unexpected transmission & engine failure while driving creates a serious risk. Engine shutoff on the highway could have led to an accident. Coolant intrusion in 1.5L EcoBoost engines is a known issue, yet Ford has failed to notify all owners. This issue affects many owners and creates major safety risks. I urge the NHTSA to investigate and consider a mandatory recall to prevent further incidents.
Mar 03, 2025
Originally, the car had Cylinder 2 misfire followed by the engine overheating. No crash, thankfully. have had this car for approximately 2 years, and put less than 30,000 miles on it. I took the car to Kings Ford Services where they discovered the engine block had been miscast resulting in engine coolant to enter cylinders 2 and 4, thus killing the engine. Spoke with Eric Hutton, Service Advisor Kings Ford Inc, (513)-683-0220 ext. 219, who said he has seen this happen multiple times with Ford Fusions and that the 1.5L has been recalled, but not the 2.0L which my car has. Per Kings Ford Repair Receipt: "Inspected the engine base part number to confirm it I'd 206 then with the engine at normal operating temperature, pressurized the cooling system to 20 PSI FOR 5 hours and the pressure dropped more than 4 PSK. Removed the spark plugs, used a borescope and found coolant has entered the cylinders. Removed the engine and replaced the long block assembly using all of the approved Ford gasket removers, parts cleaners, shampoo and metal surface prep wipes to clean all related mating surfaces per the workshop service manual. Also replaced all other related seals, gaskets, and non reusable hardware and reinstalled all components Removed for repairs in the reverse order of removal. Evachated, pulled system into vacuum, and recharged thr air conditioning system to service the engine assembly." I called Beechmont Ford who filed a claim with my warranty, but the warranty refused to aid and gave many excuses that were not true to the problem such as "it was a gasket issue not an engine" despite Mr. Hutton telling them multiple times it was the engine. I found out later their excuses were just that as Ford Inc. said the warranty expired within a year of having the car. They also had heard of this happening before, as well. Ford Inc. who was willing to pay a portion of the bill, $5,000, despite it being a manufacturing issue. Car was fixed and returned to me on 08/01/2024.
Aug 05, 2024
+ 12 more complaints for this component
UNKNOWN OR OTHER
15 complaints
Went to back up to park . The shifter would not properly work kept going back to park .I couldn't get it into neutral to push it. No warnings. Had to 1st pay for towing from where it happened to a parking space. Then called roadside service to take it to Bay Lincoln in Panama Beach.i will send the results from dealership. It could of been real serious and caused a bad accident maybe even death. I know ford had a recall on a earlier model fusion for shifter cable. If it's the same issue I want reimbursement.
Oct 11, 2025
My dashboard cover is peeling, it is made from leather, it is interfering with the heads up diplat, automatic lighting system and forward braking safety components, I have brought this to Ford to try to have them repair it dash but I am always told that the piece is considered trim and is not under warranty, I have also checked with Ford Fusion message boards and it seems there is a TSB on the exact 2017 model. Ford has basically told me to have it repaired at a automobile leather restoration company, I have gone to 2 different repair shops and was told it can’t be repaired it has to be replaced. I called Ford Corporation customer service and because they have no outstanding recalls on my vehicle they told me to report this to you
Jul 14, 2025
Leaking coolant
Jul 13, 2025
A frozen rear-view camera display image while in reverse
May 28, 2025
Car will crank, but will not move into gear. Getting an service message "Shift System Fault". Some days it will move and other days (like today) it will not. I believe the 2018 fusion (my car) was missed from the list of recalls for this service message. I contacted a Ford dealer near me. Either they don't have a transmission tech or it will take days before my car can be looked at.
Mar 24, 2025
+ 10 more complaints for this component
ENGINE AND ENGINE COOLING,ENGINE
14 complaints
The contact owns a 2018 Ford Fusion. The contact stated that the check engine warning light was displayed on the instrument panel. The vehicle was taken to an independent mechanic, where a code reader determined that there was a misfire in cylinders #1 and #3. The vehicle was taken to a dealer, where the engine misfires were confirmed, and the engine's long block needed to be replaced. Upon investigation, the contact discovered Technical Service Bulletin: 22-2229; however, the vehicle was not covered under the TSB. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the NHTSA Hotline to file a complaint. The failure mileage was 88,300.
Jul 28, 2025
The contact owns a 2018 Ford Fusion. The contact stated while driving at an undisclosed speed, the engine overheated and the check engine warning light illuminated. In addition, the contact noticed white smoke coming from the exhaust, and the engine was running abnormally rough. The vehicle was taken to the dealer, where it was diagnosed with coolant intrusion in cylinder #1, causing engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 115,000.
May 28, 2025
The contact owns a 2018 Ford Fusion. The contact stated while driving at an undisclosed speed, there was an engine misfire, and the low coolant level warning light illuminated. The vehicle was taken to the dealer where it was diagnosed with coolant intrusion into cylinder #2 and engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact was informed that the repair was not covered under Customer Satisfaction Program: 21N12. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 56,000.
Sep 03, 2024
The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle briefly hesitated and jerked, prompting the contact to pull over to the shoulder of the roadway. After pulling over, the contact observed that the vehicle was idling rough and turned off the vehicle. Upon attempting to restart the vehicle, the vehicle initially failed to start and required a jump start. The check engine warning light was illuminated. The vehicle was taken to the dealer, who observed coolant intrusion into cylinder #3, resulting in engine damage. The contact was informed that the long block needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 102,000.
Jul 15, 2024
The contact owns a 2018 Ford Fusion. The contact stated that while her son was driving 70 MPH, the check engine warning light illuminated. The vehicle began to run rough, and the driver veered to the side of the road. The vehicle was towed to the local Nissan dealer, where it was diagnosed that there was no coolant in cylinder #2, and the head gasket was blown. The driver was referred to the local Ford dealer. The driver called the local dealer and was informed that there was no recall or Customer Satisfaction Program coverage for the repair. The vehicle was shipped back to the contact's residence. The vehicle was towed to the local dealer where it was diagnosed that an engine replacement was needed. The vehicle was not repaired. The contact stated that the manufacturer had been contacted and the contact was referred to the NHTSA Hotline. The failure mileage was approximately 94,444.
Apr 11, 2024
+ 9 more complaints for this component
STEERING
12 complaints
The steering wheel is coming loose and is making it hard to drive. The car is becoming seriously dangerous. Others are having issues with this. Please let's fix these cars. I have children!
Jan 23, 2026
I was driving as normal I went to make a turn and out of nowhere my car would not turn and almost got smashed on the side of the car would not have swerved out of the way. There was no warning signs lights symptoms or anything one minute it was normal the next was what could have been a deadly situation. After getting a mechanic to diagnose it after removing the steering wheel, because initially was thought the steering column went out or broke, it was found out to be the middle of the steering wheel where it connects to the column that is suppose to be the shape of an Alan wrench was almost completely worn down to almost a flat circle. I cannot stress enough how scary and deadly this could have been to me and other motorist. This was verified by mechanics this is not normal wear and tear this has to be a defect.
May 05, 2025
No power stearing, Steering Gearbox malfunction. Power steering going out while driving is a major safety issue. Yes dealership confirmed issue and ordered parts for repair Ford dealership inspected issue and said that it needed repaired. Power steering went out while driving almost causing an accident. No warning, lights came on when the power steering went out saying that there was a power steering fault.
Feb 11, 2025
The contact owns a 2018 Ford Fusion. the contact stated that there was excessive movement in the steering when the steering column was making a clicking sound while turning to the left. The contact stated that while turning to the left, the steering wheel was seized, and the contact had to use excessive force to turn the steering wheel to the left. While pulling out of a parking space, the advance track mode and power steering loss messages were displayed on the instrument panel. The vehicle was taken to a certified mechanic who diagnosed that the steering had failed and replaced the lower control arm, tie rod, and rack and pinion on the driver's side of the vehicle; however, the failure persisted. The dealer was contacted and confirmed that the VIN was not under recall. The manufacturer was made aware of the failure and confirmed that the VIN was not under recall. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 111,000.
Feb 03, 2025
Shift system fault
Dec 24, 2024
+ 7 more complaints for this component
UNKNOWN OR OTHER,ENGINE
10 complaints
Unknown. Car will not start.
May 03, 2025
The engine is losing coolant on a daily basis; I keep gallons of it my car to keep it from running out. The safety risk is the vehicle hoses burst while driving in rush hour traffic and causing a worse delay and maybe injury to myself and passengers. I had the vehicle checked by an independent service station and they recommend a head gasket replacement or engine replacement, and the dealer just brushed me off with the head gasket may need replacing but it is not a recall item. It has not been inspected by any other agency. The check engine light is an on and off again problem -- and that's when the coolant is low the light comes on and when I refill it, it goes off. The vehicle coolant system is losing coolant every two days -- as of this date 4/28/2025, smoke comes from the oil filler cap area but none from the tailpipe. This is a frustrating situation and lawsuit waiting to happen situation that could easily be avoided -- They know it's a problem and want the consumer to reveal this frustrating and potential mega colossal problem to grow out of control.
Apr 28, 2025
Driver was driving at 55 miles per hour engine light illuminated. Car began to sputter and not drive. Ford Dealership mechanic,” DRIVEABILITY CONCERN, CUSTOMER STATES VEHICLE WILL NOT GO OVER 40 MPH AND HAS A MISFIRE PLEASE CHECK AND ADVISE. verfied engine is misfiring, hooked up scan tool and ran dets and found p0302 and p0316, #2 cylinder misfire and misfire and the first 1000 rev, ran a relitive compression test and found cylinder #2 is 25% diference than the other cylinders. pulled spark plug and put a boar scope in the cylinder and found a exhaust valve is missing a piece of the valve and the engine has ate the valve. recommend a ford long block” Owner was quoted $8553.37 for a used engine. Happened at 95,405 car is not drivable and unfixed. When owner asked what was the main cause the answers was “these cars just have bad engines”
Apr 21, 2025
Was driving and car started overheating. Looking at coolant levels, they were low. Refilled coolant and car started fine. Next day driving the vehicle, the engine shut down completely. Took the vehicle to Parks Ford dealership in Hendersonville NC to find the problem. I received a call from a service representative and he said there is a coolant intrusion into the cylinder or cylinders and the engine needs to be replaced. I asked to check for recalls and he stated none were found. I did my own research and found many vehicles with the 1.5 liter Ecoboost engine have had this issue and have had a recall in the past. I. Short, Ford has said they will not have my vehicle fixed due to the fact the 3 year warranty has expired and or 85,000 miles have been passed. I have financed this vehicle starting [XXX]. As of now my vehicle has almost 110,000 miles. Doing more research into this Ford has offered a fix for this. A new midi small block replacement and head gasket replacement. Doing more research into this, I have found the vehicle engine could possibly catch on fire if the coolant intrusion is not corrected. The Ford dealership quoted me $9,000 without tax to replace the engine. This just isn't doable. How can this not be a safety issue if the vehicle can and will shut off while driving and potentially catch on fire? Ford should replace the flawed engine design that they have been very well aware of. I am still making payments on this vehicle to own and I cannot risk driving it because it is used to transport my children and my wife, not with the safety factors involved. Help to have the manufacturer flawed design fixed to the updated design, that has no issues of the same, would help blue collard individuals a tremendous amount. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mar 13, 2025
While driving, the low oil pressure warning light illuminated on the dashboard. Within 5-10 minutes, the vehicle began to lose power and struggled to maintain speed. Over the next 15 minutes, the vehicle's performance continued to deteriorate, eventually shutting down completely. Despite multiple attempts, the vehicle was unable to be restarted, the vehicle has not been inspected and the vehicle never gave any prior warning of potential failure this was the frist and only issue I had with this vehicle I had to have the vehicle towed home due to not starting
Sep 09, 2024
+ 5 more complaints for this component
WHEELS
10 complaints
Went to got a normal free oil change. They told us they could not do a tire rotation because the lug nuts were swollen. On a 2018 car the cheap 2 piece lug nut swollen so a normal 19mm socket could not fit over to took off the tire. No recall and no free fix at the Anderson SC Ford Dealer.
Mar 19, 2024
The contact owns a 2018 Ford Fusion. The contact stated during a routine oil change and tire rotation, the contact was informed that the lug nuts were swollen and needed to be cut off to be removed. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 58,000.
Dec 11, 2023
Went to have car serviced and was told lug nuts were swollen and it was a Ford defect, but had to pay over $120 to replace lug nuts in order to get my tires rotated.
Dec 10, 2023
lug nuts are swollen and lug nut wrench does not fit on lug nuts. Had to get special tool to remove flat tire and replace lug nuts
May 30, 2023
The caps on the lug nuts fall off then the lug wrench does not fit, and the caps twist and now the dealer is charging me add to get then off, and usually I have to pay for some and it just happens again and again.lug nuts are 15.00 each.
Apr 18, 2023
+ 5 more complaints for this component
ELECTRICAL SYSTEM
8 complaints
Battery Energy Control Module (BECM) malfunction. Causing sluggish response when attempting to accelerate which has nearly caused an accident on multiple occasions. Other vehicles near the date of manufacture of this vehicle are reported having the same symptoms including potential for fire. There is a recall on similar vehicles: Fusion Energi Recall Issued: 2019-2020 - BECM Fire Risk (NHTSA: 23V440, Ford: 23S33) NHTSA Reference: NEF-107DM 23V-440 The date range of vehicles affected most likely needs to be modified to include vehicles manufactured earlier than December 2017. My vehicle, in particular, was manufactured in August 2017 and exhibits the same BECM issue, however, is not currently included in the recall.
Oct 03, 2025
The contact owns a 2018 Ford Fusion. The contact stated while starting the vehicle, the vehicle stalled. There was no warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed as a failure with the spark plugs. The contact was informed that the spark plugs needed to be replaced. While the mechanic attempted to replace the spark plugs, the contact was informed that the spark plugs fuse had detached and the spark plugs needed to be replaced. The vehicle was not repaired. The dealer was not contacted. The manufacturer was notified of the failure and a case was opened. The approximate failure mileage was 119,107.
Jun 12, 2024
The driver reported they were driving at approximately 55 MPH and began to smell something burning. They pulled over to the left shoulder and saw the trunk on fire. The fire totally destroyed the vehicle.
Feb 23, 2023
Son was driving 20 mph and Vehicle acted like it shut off, door chime started dinging, steering and brakes locked up and my son crashed into a group of trees, totaling the car. It had electrical issues prior and had shut off once before while he was in a parking lot. The auto shut off at stops worked correctly for a while and stopped working. Parking lights would come on while driving. Just a bunch of weird electronic things before final crash. The car had been repaired from a previous accident, but had been acting odd before that. I think previous owner had crashed it also and I’m wondering if that crash could have been caused by the same malfunctions. Also, air bags never deployed in either of his accidents which was very odd.
Aug 24, 2022
The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle hesitated during acceleration and then stalled with the transmission warning light illuminated. The doors were unable to open after the failure. AAA inspected the battery and informed the contact that the battery was not properly installed while the battery and bolts were the incorrect sizes. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was 44,126.
Aug 09, 2022
+ 3 more complaints for this component
ENGINE,ENGINE AND ENGINE COOLING
6 complaints
The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the low coolant warning light illuminated. The contact drove the vehicle to a safe location and the vehicle was towed to the dealer where it was diagnosed with engine failure due to a coolant leak. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The contact was informed that the repair was not eligible to be covered under TSB: 22-2333. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 78,891.
Jun 12, 2024
The contact owns a 2018 Ford Fusion. The contact stated that while checking the coolant level routinely, the contact noticed that the coolant was significantly lower than expected. The contact stated that while the coolant level was low the vehicle was driving rough while driving at various speeds. The vehicle was taken to an independent mechanic where it was diagnosed, and it was determined that coolant was leaking into the engine. The vehicle was not repaired. The contact became aware of Ford Customer Service Satisfaction Program Number: 21N12 (Vehicles Equipped with a 1.5L GTDI Engine – Short Block Replacement After Coolant Intrusion) however, the VIN was not included in the program. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 130,000.
Mar 29, 2024
At 100,000 miles the vehicle has experienced coolant intrusion in the engine resulting in the engine being seized. I was told by the Ford service rep that this is a known issue on this vehicle, but there is no type of warranty offered.
Feb 22, 2024
The contact owns a 2018 Ford Fusion. The contact stated while driving 5-10 MPH, the message "Coolant Level Low" was displayed. The contact veered to the side of the roadway and added coolant to the vehicle; however, the same message was displayed the following day while driving. Additionally, the check engine warning light was illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that cylinder #2 was misfiring due to coolant intrusion. The mechanic replaced 1 coil, 1 spark plug, and the coolant reservoir hose; however, the check engine warning light turned off temporarily and the failure persisted. The vehicle was taken back to the independent mechanic, where it was diagnosed that there was a coolant intrusion in cylinder #2, and the engine needed to be replaced. The vehicle was not repaired. The dealer was notified of the failure but did not assist. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under Ford TSB: 22-2229. The failure mileage was approximately 94,000.
Jan 09, 2024
I have a 2018 ford fusion 2.0L ecoboost with around 77k miles and started to see coolant loss with no visible signs in engine bay or below.car, rough start with error P0316 and occasional misfire. White smoke comes from exhaust on start sometimes. Also have to fill coolant every other day or so. It looks as coolant intrusion issue very common with these engines.
Dec 09, 2023
+ 1 more complaint for this component
POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM
5 complaints
At approximately 67,180 miles, a Ford dealership performed a multi-point inspection on my 2018 Ford Fusion SE with the 1.5L EcoBoost engine due to a check engine light on. The Ford dealership diagnosed the vehicle with a coolant intrusion into cylinder 2. The Ford dealership recommended the replacement of the short block and gasket kit, with an estimated repair cost of $7,465. This type of issue diagnosed for my vehicle is a known failure issue for 1.5L Ford EcoBoost engines documented in Customer Satisfaction Program 21N12, which covers coolant intrusion and engine damage in this engine type. Despite the Ford dealership diagnosis of my vehicle matching what is described in Customer Satisfaction Program 21N12, I was informed that my vehicle is not eligible. The Coolant intrusion into cylinder 2 is an issue that poses a safety risk due to engine misfires, stalling, overheating, and possible sudden loss of engine power while driving. In my case, my vehicle has become unreliable and unsafe for regular driving. A Ford dealership inspected the vehicle, confirmed and documented the issue, and the repair quote, diagnostic report and diagnostic payment receipt are available upon request. Ford has declined assistance despite the vehicle’s low mileage and clear alignment with known engine defects. I mailed a formal appeal letter to Ford Motor Company and I am filing a complaint with my state attorney general. This widespread issue affects customer safety, and vehicle safety standards and deserves further investigation, as many other Ford owners of vehicles with 1.5L EcoBoost engines have reported similar failures.
Aug 04, 2025
My car had a bad shifting linkage which I paid for out of pocket. My 2.0 Ecoboost engine is leaking coolant into my oil and makes a very loud concerning ticking noise, along with reduced engine power and sporadic/random loss of brakes. There has been recalls for these issues on most other Ford Fusion models and this one NEEDS TO BE RECALLED. My engine is going to blow any day now and I will be stuck paying for the rest of my car loan for a vehicle I cannot drive. All of the Ecoboost engines should be recalled for poor design.
Mar 24, 2025
I PURCHASED THE CAR [XXX], FEW WEEKS LATER THE CHECK ENGINE LIGHT CAME ON THEN DISAPPEARED, I WAS ALSO EXPERIENCING PROBLEMS WITH THE SEAT COOLING FUNCTION, AS THE TOUCH SCREEN CONTROLS WAS SHOWING THAT THEY WERE BOTH ON AND IT WAS STILL WINTER/RAINY SEASON OUTSIDE. I TOOK THE CAR INNTO FORD DEALER AT SAN BERNARDINO CA, THEY TOLD ME THAT MOST LIKELY IT WAS JUST A DASHBOARD LIGHT MALFUNCTION BECAUSE THE DIAGNOSTICS RESULTS CAME OUT FINE AND AFTER RESEARCHING IN OTHER MANUALS EVEN THOUGH THE SEAT COOLING FUNCTION WAS SWITCHED TO "on", THE CAR DID NOT COME EQUIPPED WITH SEAT COOLING ONLY HEATED SEATS. 3 WEEKS LATER AFTER TAKING MY CAR HOME, THE CHECK ENGINE LIGHT CAME ON AGAIN ON Y DASHBOARD, I BOUGHT AN OBDII DIAGNOSTIC TOOL, THE RESULT CAME BACK WITH 2 DIFFERENT POWERTRAIN CODES THAT WERE STRICTLY MANUFACTURER CODES. 1ST CODE WAS P1450 WHICH IS DEFINED AS UNABLE TO BLEED GAS TANK - EXCESSIVE VACCUM. 2ND CODE WAS P2196 WHICH IS DEFINED BY O2 SENSOR STUCK TRYING TO CORRECT 1ST CODE. THE P2196 EVENTUALLY CLEARED ON ITS OWN BUT THE P1450 BECAME PERMANENT. I HAD A DIAGNOSTIC MECHANIC TAKE A LOOK AT IT AND HE TOLD ME THE SAME THING, EXCEPT THAT THE MAIN CULPRIT IS THE PURGE FLOW VALVE, WHICH IS A RECALL ISSUE ON OTHER FORD FUSIONS. WHEN I PURCHASED THE CAR, I WAS SHOWED THAT THE CAR HAD NO RECALLS BUT THE "MYFORD" APP AND OWNERSHIP DIDNT TRANSFER TO ME RIGHT AWAY UNTIL 30 DAYS AFTER THE PURCHASE, WHICH IS WHEN IT FINALLY LET ME VIEWED THE CARS PRIOR SERVICE / MAINTANANCE HISTORY AND EVEN THOUGH THE CAR SALES LADY SHOWED ME VIN RECORDS WHERE IT SAYS THERE IS NO RECALLS AND IT HAD NO ACCIDENTS, RECORDS THAT SHE SHOWED ME 30 DAYS PRIOR TO ME GAINING ACTUAL OWNERSHIP THRU "MY FORD" WHEN PURCHASING THE VEHICLE. THE "MY FORD" APP STATES THAT IT SEEMS AS IF THE CAR WAS IN AN ACCIDENT IN THE PAST BECAUSE ALMOST $8000 WENT INTO REPAIRS TOWARDS TRANSMISSION AND OTHER MAIN COMPONENTS. CALIFORNIA SMOG CHECK RECORDS SHOW THAT THE CAR HAS ONLY HAD 1 TEST IN CA LAST SEPT 2023. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Apr 02, 2024
I went on a road trip to see family which needed 5 hours of travel. After returning and parking the car, I noticed a knocking noise coming from the engine bay when it was started and was idling. After doing what I could to rule out possible problems I concluded the Flexplate might be the culprit due to Recall 22N12 with Ford. A short time later, my car started to stall if I did not keep my RPM's high enough while my vehicle was stopped. After getting an inspection done with a dealership they confirmed that it is the Flexplate. The symptoms gradually got worse which is what ultimately led me to bring it in to a dealership instead of a different shop. The problem is that this repair estimate I got says this repair is going to cost me $3,000. I am arguing that my vehicle should have been on Recall 22N12. After contacting Ford and going back and forth for 2 and a half hours they told me i'm out of luck and that there was nothing they can/will do about this.
Jan 02, 2024
M 19 year old daughter purchased the 2018 Ford Fusion 1.5L FWD certified on May 10th from AutoNation Ford of Orange Park, FL on 5/10/2023. Car broke down on 7/31/23 at 93032 miles and had it towed back to AutoNation. Was told that the flexplate broke and that there was coolant intrusion in one or more cylinders. Had the car repaired using the extended warranty plan that was purchased for the engine repair. Also paid to have the flexplate replaced. Received the car back on 9/22/23 with 93041 miles. On 9/26/23, check engine light at 93173. Code read oxygen sensor and emission purge valve sensor. Did not have repaired right away so that we can save up for the cost since it wasn't covered by the extended warranty plan. The cost was going to be about 700.00. Then the car started to hesitate in traffic while making a loud "farting" noise and eventually breaking down on 11/8/23 . We were able to get it to Garber Ford in Green Cove Springs but was told by the mechanic that the car is to dangerous to drive anymore. After a diagnostic was performed, we were told that not only is the evap purge valve bad, the car now needs a new transmission. The transmission pours out as fast as they can put it in. Due to the broken flexplate being noted during the first repair, its highly likely that the warranty company will cover. Estimated cost is 10k if we approve the breakdown and they deny. If we do not approve the breakdown so that insurance can inspect and just replace the transmission it will be 7-8k.
Nov 22, 2023
BACK OVER PREVENTION
4 complaints
The contact owns a 2018 Ford Fusion. The contact stated that the center digital screen failed to illuminate, and the screen was black while the vehicle was shifted into gear. No warning light was illuminated. The local dealer was contacted. The vehicle was not diagnosed or repaired due to the VIN not being under recall. Upon further investigation, the contact related the failure to NHTSA Campaign: 25V695000 (Back Over Prevention); however, the VIN was not included in the recall. The manufacturer was made aware of the failure. The failure mileage was approximately 117,000.
Jan 26, 2026
The contact owns a 2018 Ford Fusion. The contact stated that while reversing, the back-over prevention camera displayed a black screen. Several minutes later, the message "Contact the Dealer" was displayed. The vehicle was taken to the dealer to be diagnosed, and the contact was informed that the VIN was not under recall. The dealer had not diagnosed or repaired the vehicle. The dealer referred the contact to the NHTSA Hotline to report the failure. The manufacturer was not notified of the failure. The failure mileage was approximately 88,000.
Oct 31, 2025
The contact's daughter owns a 2018 Ford Fusion. The contact stated that while starting the vehicle, the infotainment system screen was black. Additionally, the contact stated that while reversing, the rearview camera failed to activate, and the screen remained black. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the rearview camera screen needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 30,000.
Nov 08, 2023
The contact owns a 2018 Ford Fusion. The contact stated while reversing, the back-over prevention camera went blank. The contact shifted into the drive and the screen started rebooting independently. The contact stated that after turning off and restarting the vehicle, the instrument panel started flashing with the radio inoperable message displayed. The vehicle was diagnosed, and the contact was informed that the back-over prevention camera was not activated. The contact checked the fuse, and the fuse was properly secured. On another occasion, while the contact was reversing, the back-over prevention camera went blank, causing the contact to nearly strike a pedestrian. The dealer was contacted and made aware of the failure. The contact was informed that there was no recall associated with the failure. The vehicle was not repaired. The manufacturer was contacted and notified of the failure. The manufacturer confirmed that there was no recall associated with the failure and the contact provided information on how to reset the software. The contact stated that the software reset failed to fix the issue. The failure mileage was 68,000.
Aug 01, 2023
FUEL/PROPULSION SYSTEM
4 complaints
My car has stalled out coming up to a stop sign. It makes a sound coming from gas tank. I can not turn it off while pumping gas because it will not start after pumping gas. It is the purge value according to my mechanic. I know the recall on this issue is on the focus models but the fusion is basically the same car
Apr 10, 2024
Fuel vacuum system failure. Results in the check engine light coming on. Vehicle has died in the middle of the highway. Took vehicle to mechanic and they stated that this is a very common issue they have fixed in over half of the ford fusions he has seen. Vehicle will cut off and will not start. Shows a code for fuel/emissions.
Sep 08, 2022
I stopped at a gas station in 0 digit degree weather fahrenheit and when I tried to insert the pump into the capless filler, it was frozen guy the actual inner latch that opens to the tank itself. I tried to gently apply pressure and I could not get it to open after trying for 3-4 minutes. Luckily I was close to home since my gas light can come on and I didn't have a lot of gas left, but that also means my car is sitting in extreme cold right now with very little gas, which I believe poses a risk to line freezing. More important, what if I hadn't been as close to home? What if, while trying to drive around and fine someone to help me, I ran out of gas? If a person was in a more rural environment then I am, they might not be quickly seen and might be stranded with a car that can't provide heat any longer and in extreme cold.
Jan 08, 2022
WHILE DRIVING ON I-95 IN EXTREMELY HEAVY TRAFFIC THE 2018 FORD FUSION SUDDENLY DECELERATED AND INDICATING LIGHTS CAME ON. IT WAS HARROWING AND EXTREMELY DANGEROUS TO NAVIGATE THE DISABLED VEHICLE. THE FORD DEALER STATES THE THROTTLE BODY NEEDS TO BE REPLACED. THIS IS INTERESTING SINCE, THE CAR IS ONLY SIX MONTHS OLD. ADDITIONALLY, THIS IS A KNOWN ON OTHER (OLDER) FORD MODELS WHICH MAKES ME SUSPECT THEY ARE USING KNOWN DEFECTIVE PARTS.
Jul 11, 2019
ELECTRICAL SYSTEM,UNKNOWN OR OTHER
4 complaints
Trunk pops open randomly often. It’s popped open while driving and will cause accidents if items fall out, it’s happened multiple times without any possibility of button being hit.
Feb 01, 2024
car knob shifts into reverse or drive without being touched when sitting in park at random times, have nearly hit basketball pole due to being unprepared to hit break. The knob makes a robotic type sound, an automated turning type sound & switches without being touched, has happened several times but not every time
Feb 01, 2024
The entire computer system does not function. The screen, radio, everything has turned completely off in the middle of driving on the highway. It’s concerning what this will cause at some point. It used to do this intermittently, now it’s completely off and I’ve had it to multiple mechanics who have checked everything thoroughly and cannot find anything wrong. Two mechanics told me in 20-30 years as a mechanic theyve only seen this once or twice but couldn’t be fixed. I owe a ton of money on my car, it my only transportation for myself kids and elderly mother, my daughter is a new driver and having everything electrical shut down while driving is going to cause an accident and panic.
Feb 01, 2024
AT A RENT-A-CAR FACILITY IN ABSECON, NJ, CUSTOMER RETURNED THE VEHICLE COMPLAINING THAT THE VEHICLE WOULD NOT STAY LOCKED. CAR WAS PARKED, NO DOORS WERE AJAR (RENTAL AGENT MADE SURE OF IT), LOCKED VEHICLE, AND TRIED THE HANDLES. FOUND AFTER ONE OR TWO PUMPS ON ANY HANDLE THE VEHICLE WOULD UNLOCK ITSELF. EVEN TRIED TO LOCK WITH THE EJECT KEY IN THE FOB ITSELF AND THE SAME RESULT OCCURRED. CHECKED BACK LOG ON VEHICLE FOR KEY CODE ON THE DRIVER DOOR TO FIND NO SUCH CODE AVAILABLE. THIS MAY BE AN ELECTRICAL/FUSE ISSUE REGARDING THE DOOR LOCK ACTUATORS.
Mar 02, 2020
SEAT BELTS
3 complaints
Rear seatbelt driver side seat belt does not click or buckle at all. Nothing is stuck in it and it has never buckled as long as I’ve had the car
Dec 14, 2025
The contact owned a 2018 Ford Fusion. The contact stated that while driving at 65 MPH, the front driver side seat belt did not buckle appropriately, another vehicle driving at an unknown speed moved to the left lane, then the other vehicle changed lanes again moving in front of the contact, and the other vehicle abruptly depressed on the brakes causing the contact to rear end him. The vehicle came to a stop and merged into the shoulder. The vehicle was damaged on the front driver's and passenger's side. There were no warning lights illuminated. The driver’s and passenger’s side air bags did deploy however the seat belt did not retract the contact, causing the contact to be injured. There was no property damage. A police report was filed. The contact sustained a concussion and his eyes swelled shut. It was unknown if the other driver in the other vehicle sustained any injuries. The insurance company towed the vehicle to an impound lot and then towed it to Copart. The vehicle was deemed a total loss by the insurance company. The manufacturer was not notified of the failure. The dealer was not made aware of the failure. The failure mileage was 89,000.
Mar 20, 2025
WHEN SEAT BELT IS DETACHED FROM EITHER DRIVER OR PASSAGER NO INDICATOR WHILE DRIVING. IT INDICATES AFTER DRIVING FOR 2 MINUTES.
Mar 15, 2018
ENGINE,FUEL/PROPULSION SYSTEM
3 complaints
I would like to respectfully request that my 2018 Ford Fusion, with the 1.5L EcoBoost engine, be considered for inclusion in the customer satisfaction programs related to the engine issues I'm experiencing. Despite my vehicle not being initially listed, the problems I've encountered, including the diagnostic trouble code P0302 and the coolant leak into cylinder #2, suggest that it may be suffering from a similar defect or design flaw that the program aims to address. Given the safety risks associated with the current condition of my vehicle, I believe it would be fair and reasonable to include it in the program and provide the necessary repairs or replacements to ensure the vehicle is safe to operate. I would appreciate your assistance in facilitating this process and exploring options for resolving this issue in a manner consistent with the treatment of similar vehicles.
Aug 19, 2025
Coolant intrusion, coolant and oil is mixing causing my car to run hot. Engine light keeps coming on, repairs to multiple pumps replaced, water pump replaced, spark plugs replaced, radiator replaced, thermostat replaced. Ford dealership tried replacing all the above vehicle is still running hot. Now claiming I need a new engine.
Jul 23, 2025
CHECK ENGINE LIGHT, LOTS OF WHITE SMOKE OUT OF TAILPIPE AND DARK BLACK SPARK PLUGS AT 15,000 MILES! DEALER SAID I GOT BAD GAS OR VANDALISM THEREFORE NO WARRANTY COVERAGE. I HAD TO PAY A LOCAL MECHANIC TO REPLACE SPARK PLUGS, PUMP OUT AND REPLACE FUEL. TWO WEEKS LATER I RECEIVE A FORD LETTER STATING COOLANT CAN LEAK INTO THE CYLINDER BORES CAUSING EXACTLY HAPPENED TO MY VEHICLE. NOW I HAVE TO SEEK REIMBURSEMENT.
Jan 22, 2020
AIR BAGS
3 complaints
I went to head on to a light pole and my passenger side airbags did not deploy
Jan 07, 2024
I WAS HIT BY A TOYOTA HIGHLANDER ON HWY 12 CA WHILE WAITING FOR THE LIGHT TO TURN GREEN. THE TRUCKS APPOX. SPEED 40 TO 50 MILES AN HOUR,SPRAIN NECK,LOWER BACK SEVER PAIN REPTURED BREAST IMPLANT KNOCKED FRONT TOOTH IMPLANT OUT ..AIR BAGS DID NOT COME OUT CAR IS TOTALLED.I WAS AT A DEAD STOP. I WAS ON HWY THERE WAS A SHERIFF RIGHT BEHIND THE GUY WHO HIT ME HE WAS ON CELL PHONE. MY PASSENGER PULLED REAR OUT ENOUGH TO GET IT TO MY HOUSE SO IT WAS NOT TOWED. I WENT TO EMERGENCE AFTER I GOT HOME
Apr 30, 2021
TAKATA AIRBAG. RECEIVED NOTICE OF AIRBAG RECALL OVER TWO YEARS AGO (JULY 2016). STILL TO REMEDY. WE WANT TO USE THE VEHICLE FOR VACATION TRAVEL BUT ARE WORRIED ABOUT THE SAFETY OF THE PERSON IN THE PASSENGER SEAT.
Sep 29, 2018
VEHICLE SPEED CONTROL,ENGINE
2 complaints
My Engine is on my car will not go over 25 miles and if it does it shakes and I place the car in park or shut it off u can hear like water sound coming from the engine were it’s seems as if it was boiling
Dec 17, 2025
I heard fluid from what seemed like my dashboard and a puff of white smoke, no sensors came on. My Ford fusion continued but ran rough. I was pulling out of a parking lot onto the street and my Ford fusion was nearly t-boned because it would not accelerate. Later that day my overheat sensor came on and my fusion left me stranded on the side of the road in the middle of nowhere with a baby in 100 degree heat. I called a local mechanic, he put water in it and drove it to his shop. After 400 dollars worth of work the problem persistent, he then checked it for the notorious coolant intrusion issue and confirmed a misfire and coolant intrusion in cylinder 2. It's now parked and has not been driven in 3 months.
Dec 11, 2023
POWER TRAIN,UNKNOWN OR OTHER
2 complaints
Shift actuator wouldn’t go into gear I was stranded a few times had to be towed twice. I’ve found a plastic bushing that showed a $4.00 part could be responsible. Deadly for us disabled Vietnam veterans . I can’t walk. Maine has 200 vehicles with the same issues nationwide who knows supposedly the actuator will not be made by ford motors until February 2026. I’m 76 years old this is a hazard I can’t afford to buy another car. Please help us. Or get stranded in the middle of nowhere freezing cold Thank you
Dec 07, 2025
GEAR DIAL STUCK IN PARK MODE. GEAR DIAL I WILL NOT MOVE. WHEN THE PROBLEM FIRST STARTED THEN TURNING THE CAR ON AND OFF AND TRYING OVER AND OVER I WAS ABLE TO GET IT INTO GEAR. THIS LAST TIME THAT DIDN'T WORK. ATTEMPTED TO GET THE CAR IN NEUTRAL USING THE NEUTRAL OVERRIDE METHOD BUT IT FAILED. CAR HAD TO BE WENCHED ONTO THE TOEING TRUCK WHILE STUCK IN GEAR. PROBLEM BEGAN OCCURRING AT 40,000 MILES. THE BATTERY IN THE CAR DIED FROM LEAVING THE LIGHTS ON AND THIS SEEMED TO 'RESET' THE PROBLEM AND NO ISSUES FOR 6 WEEKS. ORANGE WRENCH WARNING SIGN APPEARED AGAIN AND NOW THE CAR IS STUCK IN PARK AND HAVE TO TOW IT TO A FORD DEALER. I ALSO NOTICED THAT WHEN THIS PROBLEM OCCURRED THE BLUE ANTI THEFT LIGHT CONSTANTLY FLASHES. AFTER THE BATTERY DRAINED AND THE PROBLEM RESET THEN I ACCIDENTALLY HIT THE LOCK BUTTON TWICE AND THIS IS WHEN THE BLUE LIGHY STARTED FLASHING AGAIN AND I WAS UNABLE TO GET THE VEHICLE OUT OF PARK MODE. WHEN I FIRST PURCHASED THE VEHICLE AT 40,000 MILES I WAS DRIVING THE INTERSTATE AND THE BLUE ANTI THEFT LIGHT BEGAN FLASHING AND THE CAR ALARM SOUNDED WHILE I WAS AT A 75 MPH SPEED. I HAD TO STOP THE CAR, TURN IT OFF, HIT THE UNLOCK BUTTON ON MY KEY FOB TO GET THE. ALARM TO STOP SOUNDING. I BELIEVE THE TWO ISSUES MAY BE RELATED AS THEY HAPPEN AT THE SAME TIME. THE ORANGE WRENCH ONLY APPEARS WHEN THE CAR WILL NOT GO IN GEAR. WHEN THE CAR HAS EASILY GONE IN DEAR THE ORANGE WRENCH IS NOT PRESENT. AGAIN, I AM UNABLE TO ENGAGE THE NEUTRAL OVERRIDE BY USING THE KEY IN THE OVERRIDE SLOT. THE LIGHTS WILL FLASH ON THE DIAL BUT THE CAR WILL NOT GO INTO NEUTRAL, IT REMAINS STUCK. I HAVE TRIED MANY TIMES AND HAD OTHERS TRY IT AS WELL SO I KNOW IT'S NOT USER ERROR. CAR ALARM GOES OFF WHILE DRIVING ON THE INTERSTATE.
Jan 29, 2021
POWER TRAIN,UNKNOWN OR OTHER,ENGINE
2 complaints
The car issued no warning, lights or messages prior to the damage. My [XXX] son was driving and the car started shaking which really scared him as he’s a new driver. I would say the safety of him and other drivers on the road were definitely put in danger. The vehicle has been inspected by a Ford dealership. They stated it had a broken flex plate and short block. Broken Flexplate; Diagnostic $210.00 Parts $1,345.86 (Flexplate, transmission fluid pump, filter, one time use parts) Labor $2,600.00 ($200.00 x 13.0hrs) Sales Tax $125.84 Total $4,281.70 Short Block replacement; Diagnostic $145.00 Parts $2,193.64 (Short block engine/kit, spark plugs, one time use parts) Labor $4,480.00 ($200.00 x 22.4hrs) Alignment $159.95 Sales Tax $205.11 Total $7,183.70 Tow Bill $140.00 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Jul 31, 2025
While driving down the road the car suddenly flashed engine coolant is over-temperature warning and shut off and lost power. Inside of my vehicle the car was not showing it was running hot on the temperature hand. I was on a blind curve and barely made it to a pull off before the car completelyshut off. There have been no signs of over heating before this. There is a coolant intrusion in the cylinder and the engine block needs to be replaced. 120000 miles and out of warranty.
Jan 07, 2023
ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE
2 complaints
On 4 occasions, the car has shut off while moving and in traffic. A dashboard message appears, saying "full accessory mode". After coming to a stop, the car will immediately restart. My obd reader shows no error codes. The car has 18,000 miles on it and this problem occurs randomly. It happened first when the car was a few weeks old. I took it to dealer and they found no problem. Ot has happened 3 times since then. This problem has been reported at least 15 times on the ford fusion sport forum.
Feb 05, 2025
My car shuts down for some reason while I’m driving and has been running rough for the last couple of days. Also my horn does not work at all. This is a hazard for not only me but everybody. My vehicle have not been inspected, or not that I know of. When I first brought the car 2 years ago I noticed the horn was weak but was told that’s how they sound. I forgot when my check engine light came on but it had to be 2 or 3 months ago. Just recently my car started to stop on me while I’m in traffic, the first time it happened was in June. I also went to Autozone to see why the check engine light, but it only says small EVAP leak.
Aug 12, 2022
ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM
2 complaints
I drive a 2018 Ford fusion ecoboost. It started with a misfire on cylinder 4 and in that same week the engine started to over heat. Had the spark plugs replaced. Upon checking and monitoring coolant levels noticed I was losing coolant. Wasn't having any puddles in the driveway and no visible leaks under the hood. After few trips to work and home the engine would overheat and my work is less than 2 miles from my home. Started to quickly get worse, more codes popping up on my fixt obd2 scanner. From po304, PO300, PO303, B124D, PO313, PO316, PO317.
Aug 11, 2024
Coolant is leaking into my oil.
Jan 29, 2024
FUEL SYSTEM, GASOLINE
2 complaints
The contact owns a 2018 Ford Fusion. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic and was diagnosed with a failed EVAP purge system. The contact was informed that the EVAP purge system needed to be replaced. The vehicle was not repaired, and the failure reoccurred. The contact stated that the fuel tank made a vibrating sound before the vehicle stalled. Additionally, the contact stated that after refueling the vehicle, the vehicle failed to restart immediately. The contact stated that the vehicle restarted after several attempts. The dealer was contacted and made aware of the failure and a service appointment was scheduled. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 79,000.
May 22, 2024
The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the check engine warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed that the EVAP valve failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 71,000.
Feb 07, 2023
FUEL SYSTEM, OTHER
2 complaints
The contact owns a 2018 Ford Fusion. The contact stated that after starting the vehicle and driving from a complete stop, the vehicle made abnormal rattling sounds. The contact stated that the failure ceased while driving 40 MPH however, the failure recurred while driving below 40 MPH. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the flywheel was fractured and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 80,000.
May 08, 2023
The contact owns a 2018 Ford Fusion. The contact stated while driving at 50-55 MPH, she heard an abnormally loud sound coming from the front the of the vehicle. There was no warning light illuminated. The contact was able to drive to her residence, where she turned off and restarted the vehicle. However, the failure persisted. The vehicle was towed to the dealer where it was diagnosed that the flywheel needed to be replaced. The part was replaced; however, the failure reoccurred a year later. The vehicle was taken to an independent mechanic where it was diagnosed that the flywheel needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline and a case was filed. The failure mileage was unknown.
Sep 28, 2022
FUEL SYSTEM, GASOLINE,POWER TRAIN
2 complaints
The contact owns a 2018 Ford Fusion. The contact stated that the vehicle failed to start soon after refueling. Additionally, while stationary and while driving at various speeds, the vehicle would hesitate or stall upon depression of accelerator pedal. The contact also stated that the powertrain warning light would intermittently appear on the instrument panel. The manufacturer was notified of the failure and the contact was informed that there were no open recalls on the VIN. The vehicle was not repaired. The failure mileage was unknown.
Apr 17, 2023
The contact owns a 2018 Ford Fusion. The contact stated that while starting the vehicle and shifting into reverse(R), she was unable to shift between gears. There was no warning light illuminated. The vehicle was towed to the residence. The vehicle was then towed to an independent mechanic, where it was diagnosed that the under hood shifter cable bushing needed to be replaced. The vehicle was repaired. Additionally, the contact stated that the vehicle was taken back to the mechanic for routine oil change service; however, while driving at an undisclosed speed, the check engine warning light was illuminated. The vehicle was taken back to the independent mechanic, where it was diagnosed that the canister purge valve (CPV) needed to be replaced. The contact stated that the part was replaced; however, the vehicle stalled after being refueled. The vehicle was taken back to the mechanic, where the failure could not be duplicated. The vehicle was not repaired. The dealer was not contacted. The manufacturer was made aware of the failures and confirmed that the VIN was not included in NHTSA Campaign Numbers: 18V735000 (Fuel System, Gasoline) and 22V413000 (Power Train). The manufacturer advised the contact to file a complaint with the NHTSA hotline. The approximate failure mileage was unknown.
Mar 27, 2023
UNKNOWN OR OTHER,BACK OVER PREVENTION
2 complaints
The audio/navigation display screen on my 2018 Ford Fusion went black as I was backing out of a parking spot almost causing an accident. It immediately came back on after this but unfortunately, it started to happen regularly upon startup, while driving, parked, just randomly, and for longer periods of time. It also started to increase the volume and I couldn't control it. The system completely stopped working after several weeks. I did a lot of research and noticed that this is a significant problem with Ford Accessory Protocol Interface Modules (APIM). Some have already been recalled on certain models of Fords and why they are not recalled on any that go out is beyond me. Seems that in and of itself would place some liability on the manufacturer in the event of an accident. The dealership wants to charge over $1,200 to replace the faulty APIM, which they described as a continued problem that everyone knows about. So maybe that is the reason it is not recalled. They can make money selling the vehicle and then another $1,200 after 40,000 miles when it goes out. I am very frustrated and will now be $1,200 less happy. Yes, I am frustrated at the financial impact, but it was a safety issue initially and at times startled me while driving, which could have caused an accident. I am sure that there are numerous examples of previous complaints that are able to prove this.
Feb 18, 2022
Faulty APIM for radio/navigation/rear view camera. System won’t turn on or operate In cold weather. When warm, system works perfect.
Jan 13, 2022
SERVICE BRAKES
2 complaints
2018 FORD FUSION. CONSUMER WRITES SEEKING REIMBURSEMENT FOR SAFETY RECALL 19S54. *LD *JS
Aug 19, 2020
ABS PUMP FAILURE. ABS PUMP FAILS DURING AN ANTI-LOCK EVENT CAUSING PEDAL TO GO TO FLOOR AND NO STOPPING POWER. OCCUR SPORADICALLY WHEN ON ICE/SLUSH/SNOW OR WHEN BRAKING ON A ROUGH RODE.
Mar 16, 2017
ELECTRICAL SYSTEM,UNKNOWN OR OTHER,BACK OVER PREVENTION
1 complaint
What component or system failed or malfunctioned, and is it available for inspection upon request? The APIM (Accessory Protocol Interface Module) appears to have failed. The vehicle's infotainment/play screen is completely blank and unresponsive. This module controls key systems including climate control, navigation, hands-free calling, and the backup camera. The component is available for inspection if needed. How was your safety or the safety of others put at risk? This failure compromises several safety-critical functions. I am unable to adjust climate settings, use GPS navigation, make hands-free emergency calls, or see through the backup camera. These features are essential for safe driving, especially in adverse weather or while reversing. Has the problem been reproduced or confirmed by a dealer or independent service center? Not yet confirmed by a dealer, but the issue has been consistent. I have attempted both soft and hard resets, and verified the fuses are good. All symptoms point to an APIM failure. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No formal inspection has been done by the manufacturer, police, or insurance. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? There were no warning lamps or messages. The issue started intermittently about two months ago. Resets worked temporarily, but the screen is now completely unresponsive.
Oct 18, 2025
SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING
1 complaint
The contact owns a 2018 Ford Fusion. The contact stated that the vehicle was idling roughly with the check engine warning light illuminated. The vehicle was taken to the dealer, who suggested that the spark plugs be replaced and a tune-up be performed based on the mileage. The dealer performed the spark plug replacement and tune-up, and the check engine warning light was no longer illuminated; however, the vehicle was still idling roughly. The vehicle was returned to the dealer, who diagnosed the vehicle with coolant intrusion into the engine. The contact was informed that the engine had failed and needed to be replaced. The dealer diagnosed the vehicle and determined that the rear brakes and rear brake rotors needed to be replaced due to a brake fluid leak. The vehicle was not repaired. The contact was informed of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic); however, the VIN was not included. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case. The manufacturer informed the contact that the VIN was not under recall or special programs for the repair. The failure mileage was approximately 73,000.
Aug 20, 2025
EXTERIOR LIGHTING
1 complaint
Known issue with 2013 Models through 2019, Sunroon leaks under heavy rain even if the Drains are cleaned and cleared. I spoke with Ford and they said it is not their issue since there is no recall. This has been posted under multiple site that there are hundreds of people effected by this.
Jul 28, 2025
STEERING,TRACTION CONTROL SYSTEM,ENGINE
1 complaint
The contact owns a 2018 Ford Fusion. The contact stated that while driving at various speeds, the vehicle shuddered upon depression of the accelerator pedal. The contact stated that while at a complete stop, there was an abnormal popping sound coming from the vehicle while depressing the accelerator pedal. The failure persisted, and the contact stated that the steering wheel was loose while operating the vehicle. The contact stated that the traction control warning light flashed on the instrument panel during one of the failures. The vehicle was not yet diagnosed or repaired. The manufacturer was notified of the failure and informed the contact that there were no recalls on the VIN related to the failure of the vehicle. The contact was referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 41,000.
Jun 11, 2025
AIR BAGS,SERVICE BRAKES
1 complaint
Accident caused by brakes slipping and failing to stop even when pushed all the way down to the floor. Air bags failed to deploy. Resulting in a total loss estimate after accident.
May 10, 2025
UNKNOWN OR OTHER,ENGINE,FUEL/PROPULSION SYSTEM
1 complaint
Unknown. Car will not start, dashboard says overheating, white smoke was coming out of muffler but stopped and etc.
May 03, 2025
UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM
1 complaint
EVAP system leak. Vapor leak causes car to not start after putting gas in the tank. It takes several tries before the car starts up. Engine light stays on which causes car fob not to auto start.
Nov 21, 2024
ELECTRICAL SYSTEM,SERVICE BRAKES,ENGINE
1 complaint
While waiting at a red traffic light in drive and on a slight incline, engine shut off by itself and car started rolling backward with my foot on the brake pedal. The pedal felt harder than normal to push but didn't stop the car. A car stopped behind me was put at risk of impact with the rear of my vehicle. I could see I was getting closer and closer to hitting the other car. As this was happening, i pushed the start button and managed to restart the engine and put it in drive to pull away just before impact. Problem hasn't been reproduced by anyone. Vehicle or components haven't been inspected by anyone. No warning light lamps or other symptoms of the problem prior or during remaining drive home. I don't know if this is related but the car does have a random no start symptom due to a battery discharge condition while parked overnight. This happens very rarely and is not reproducible when the battery is charged. Ford has a TSB ref.17-2192 on this failure that is applicable to my VIN but they will not cover it since my car is out of warranty (Time and 73K miles). The dealer further stated that there is no guarantee that this re-programming of the PCM will fix the problem. The Ford dealer gave me an estimate of $214 for the re-programming of the PCM and it does not include a new battery if it needs it. I have an appointment to get it done on 11/22/24 but I'm reluctant to pay for something that may not fix the parasitic PCM draw on the battery. Any advice would be appreciated. Thank you.
Nov 20, 2024
SERVICE BRAKES, HYDRAULIC
1 complaint
The contact owns a 2018 Ford Fusion. The contact stated that while driving at 45 MPH, the brake pedal was depressed and hesitated to come to a stop. In addition, there was fuel leaking from the rear of the vehicle. The vehicle was inspected by an independent mechanic who confirmed that the brake fluid was leaking from the hose. The vehicle was not repaired. The VIN was not included in NHTSA Campaign Number: 23V162000 (SERVICE BRAKES, HYDRAULIC.)The manufacturer was not notified of the failure. The failure mileage was unknown.
Oct 16, 2024
POWER TRAIN,ELECTRICAL SYSTEM,ENGINE
1 complaint
The contact owns a 2018 Ford Fusion. The contact stated while his wife was driving 60 MPH, the wrench symbol became displayed. The power train fault warning light was illuminated. The vehicle started to shake with the check engine warning light illuminated. The power steering was inoperable. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 58,000.
Oct 07, 2024
ENGINE AND ENGINE COOLING,POWER TRAIN
1 complaint
The contact owns a 2018 Ford Fusion. The contact stated while driving 45 MPH, the engine started to overheat, and there was smoke coming from underneath the hood. The message "Vehicle Temperature Overheating" was displayed. The contact pulled over to the side of the road and allowed the vehicle to cool down. The contact was able to continue driving; however, the failure recurred several times while driving. The contact pulled to the side of the road several times until arriving to the residence. The vehicle was taken to the dealer, where it was diagnosed that the PCM had failed. Additionally, the dealer diagnosed there was coolant intrusion in the engine cylinders. The dealer determined that the engine needed to be replaced. The vehicle was not repaired. The contact related the failure to Ford Campaign Number: 21N12. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 181,000.
Aug 16, 2024
FUEL SYSTEM, GASOLINE,ENGINE
1 complaint
The contact owns a 2018 Ford Fusion. The contact stated that while driving or while stopped at a traffic light, the vehicle stalled. The vehicle was sputtering while driving at various speeds. The check engine warning light was illuminated. The contact stated that after refueling, the vehicle failed to restart. The vehicle was taken to an independent mechanic, who informed the contact that the failure was due to the canister purge valve. The vehicle was taken to the local dealer, where it was diagnosed that the canister purge valve was stuck. The vehicle was not repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 113,000.
May 08, 2024
ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE
1 complaint
The contact owns a 2018 Ford Fusion. The contact stated while driving 30 MPH, the vehicle stalled with the check engine warning light illuminated. The vehicle was able to be restarted; however, the failure persisted. The contacted stated that the failure persisted, and the vehicle would not restart. The vehicle was taken to an independent mechanic where it was diagnosed as a malfunction with the gas cap. The contact was informed that the gas cap needed to be replaced. The dealer was not contacted. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 73,000.
Apr 29, 2024
ELECTRICAL SYSTEM,SEAT BELTS
1 complaint
The Accessory power interface module has failed. It receives inputs from a variety of sensors, some hardwired directly to it, while most are sent over the bus communications system from the Powertrain Control Module (PCM). These inputs allow the module to communicate with the steering wheel controls, the radio, navigation system and the consumer's personal cell phone via Bluetooth. When I contacted Ford they said there was nothing they were able to do because there is no active recall for this model/year. I strongly feel as if this is a safety hazard due to not only my steering wheel controls being inoperable, but my cruise control, HVAC system, and navigation system, rear camera system, audio system, Bluetooth, to be faulty and not work. Additionally the on the driver seat the part that the seat belt clicks into broke
Jan 24, 2024
POWER TRAIN,ELECTRICAL SYSTEM
1 complaint
The contact owns a 2018 Ford Fusion. The contact stated that while reversing at approximately 5 MPH, the transmission unintendedly shifted into park(P). Additionally, the contact stated that he became aware that the shifter cable bushing had detached after not being able to start the vehicle. The shifter cable bushing was attached, and the vehicle was able to be started. The brakes, engine, and battery warning lights were illuminated. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 78,879.
Aug 29, 2023
VISIBILITY/WIPER
1 complaint
While driving on PA Turnpike westbound, in the rain, my windshield wipers suddenly stopped working. THANKFULLY, I was in the far left lane and able to pull off to the shoulder safely. Once rain stopped, I was able to take my car to my mechanic. Stated that my cars windshield wiper motors both failed AND melted, causing them to stop working.
Aug 26, 2023
SUSPENSION
1 complaint
my vehicle axel and suspension broke while driving vehicle hit driver side curb while in turning left lane at the intersection during the green light to avoid another vehicle driving unsafe. Hitting a curb should not have cause vehicle axel and suspension to collapse. This could have caused major accident because vehicle behind me could have ran into the rear end of my vehicle while in the turning. Also particles were falling from underneath the vehicle while trying to get vehicle over to the far right lane out of the way of other vehicles.
Jul 29, 2023
STEERING,LANE DEPARTURE
1 complaint
While navigating a corner, suddenly vehicle became difficult to steer, numerous warnings became came active on dashboard for Steering Assist Failure, AdvanceTrac Failure, Hill Start Assist Failure. A collision into a ditch was narrowly avoided.
May 23, 2023
UNKNOWN OR OTHER,POWER TRAIN
1 complaint
The transmission jumps, doesn’t want to shift gears, revs up on its own. The recall for the fusions year models 3013-16 is the same thing my car is doing.
Mar 16, 2023
EQUIPMENT
1 complaint
Android Auto is incredibly unresponsive to user input. Using a Moto G Power cell phone (~2 years old...no performance issues when not using Android Auto), the screen lags for 5-10 seconds between inputs, requiring the user to make many attempts to press the cars Ford Sync 3 Infotainment screen. This is forces the user to take their eyes off the road for way longer than is safe. The quality of Google and Android Auto is considerably worse than Ford's native Sync 3 system...frankly Android Auto is dangerous. Tried this with multiple cables, and even other phones, and in other Ford vehicles and it is just as unresponsive. I don't understand how something so unregulated (Android Auto) is permitted to be used natively in vehicles. I believe car infotainment systems are supposed to be using "Realtime OS's", and I highly doubt Android Auto is doing this.
Mar 15, 2023
LATCHES/LOCKS/LINKAGES
1 complaint
The contact owns a 2018 Ford Fusion. The contact stated while driving 30 MPH, the trunk unlatched independently. The vehicle was not taken to be diagnosed or repaired. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was 67,205.
Mar 13, 2023
ELECTRICAL SYSTEM,UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM
1 complaint
When I stop to get fuel/gas for my car, I am unable to turn the ignition off because if I do, the car will not restart immediately or at all. There is also a jerking motion immediately after fueling and while driving. There is a "wailing" noise immediately proceeding the car shutting down. The check engine light is on.
Jan 05, 2023
POWER TRAIN,SEAT BELTS
1 complaint
The passenger seat belt is hard to buckle it gets stuck making it hard to even buckle up. And the shifter bushing broke had to use the key in the override shift to get it to shift so I could get it home, my father is the one who found the issue. We will be taking it in to the ford dealership to be looked at and to get fixed. The shift sys fault service required light did come on prior to it not shifting into gear.
Aug 01, 2022
SUSPENSION,ENGINE,FUEL/PROPULSION SYSTEM
1 complaint
My transmission has start to work weirdly. My car started vibrating when I am driving slow. When move to second gear suddenly the car make stop and move again.
Jul 02, 2022
BACK OVER PREVENTION,EQUIPMENT
1 complaint
The contact owns a 2018 Ford Fusion. The contact stated that while driving the infotainment touch screen went black with no warning. The contact stated that the rearview camera and hands-free feature were inoperable. The vehicle was taken to a dealer where the failure was diagnosed with a failed Accessory Protocol Interface Module (APIM). The contact stated the APIM was not communicating with the vehicle. The APIM needed to be replaced. The contact stated that the vehicle was not been repaired due to the cost. The manufacturer was notified of the failure and informed the contact that there was no recall associated with the vehicle. The contact was then transferred to NHTSA to file a complaint. The approximate failure mileage was 60,000.
Apr 14, 2022
ENGINE AND ENGINE COOLING,UNKNOWN OR OTHER
1 complaint
Ford issued a recall in 2020 for my car for coolant leaks. My vehicle was under warranty at the time (28k miles), and in the same week had white smoke emissions, engine stalling on the interstate and overheating in idle. The smoke never went away even after extensive, month long repair. The vehicle again had the same issues in august 2020 (76k miles), taken to Ford dealership with $3,000 in out of pocket expense. It is now March 2022 (82k miles) and my vehicle is still showing signs of coolant leak with no help from any Ford dealership.
Mar 03, 2022
POWER TRAIN,VEHICLE SPEED CONTROL,UNKNOWN OR OTHER
1 complaint
MISSOURI
Oct 22, 2021
POWER TRAIN,VEHICLE SPEED CONTROL
1 complaint
I FIRST NOTICED HARSH SHIFTING AND DELAYED SHIFTING. THEN I WAS PULLING OFF FROM THE CAR WASH AND MY GEARSHIFT JUMP GEARS FROM NEUTRAL TO REVERSE BUT NOT DRIVE HOWEVER THE CAR DID MOVE FORWARD. I HAD THE VEHICLE TOWED TO WINNER GORD WHERE THEY IMMEDIATELY KNEW WHAT THE ISSUE WAS BECAUSE THEY SAID ITS COMMON. WHEN I GOT MY VEHICLE BACK THE HARSH/DELAYED SHIFTING WAS STILL AN ISSUE. WEEKS LATER THE CAR IN ADDITION TO HARSH AND DELAYED SHIFTING IT NOW SHAKES REALLY BAD.
Apr 23, 2021
POWER TRAIN,AIR BAGS,UNKNOWN OR OTHER
1 complaint
I WAS DRIVING ON THE HIGHWAY AND ALL OF A SUDDEN A WRENCH SENSOR POPPED UP ALONG WITH THE AIRBAG SENSOR AND THE CAR STARTING DE-ACCELERATING AND SHAKING AND I HAD TO PULL OVER. I WENT TO A MECHANIC AND THEY SAID THAT THE THROTTLE BODY WAS DIRTY SO THEY CLEANED IT AND THEY CLEARED THE CODE BUT IT RECENTLY HAPPENED TWO MORE TIMES. WHEN IT HAPPENS IT MAKES THE CAR NOT ABLE TO START AS EASILY. IT'S REALLY DANGEROUS BECAUSE IT MAKES IT TO WHERE THE CAR WILL JUST NOT ACCELERATE AND IF YOU ARE ON THE HIGHWAY THERE ARE CARS FLYING RIGHT PAST YOU. THIS HAS HAPPENED A TOTAL OF 3 OR 4 TIMES.
Mar 02, 2021
STRUCTURE
1 complaint
BACK PASSENGER DOOR UNLATCHES WHILE DRIVING SPORADICALLY. FORD PREVIOUSLY HAD A RECALL ON THE 2016 MODEL HOWEVER, THEY ARE STATING THAT THIS DOES NOT FALL UNDER THE RECALL. MY 4 YEAR OLD SON SITS IN THE BACK SEAT IN HIS CAR SEAT. THIS IS EXTREMELY DANGEROUS. MY VEHICLE IS AT THE DEALERSHIP NOW AND THEY ARE FILING A CLAIM THROUGH MY 3RD PARTY WARRANTY COMPANY AND MAKING ME PAY FOR THE DEDUCTIBLE AND I SUSPECT THE LOANER VEHICLE. I JUST PURCHASED THE VEHICLE IN MARCH 2020 AND I HAVE NOTICED IT WHEN SINCE PURCHASE. *TR
Jul 03, 2020
ELECTRICAL SYSTEM,ENGINE
1 complaint
WHILE STOPPED AT A INTERSECTION FOR A RED LIGHT THE CAR COMPLETELY DIED. I COULDN'T TURN ON THE EMERGENCY FLASHERS, ROLL DOWN WINDOWS OR UNLOCK DOORS. EVERYTHING WAS DEAD. I WAS IDLING AT THE STOP LIGHT WHEN THIS HAPPENED.
Feb 27, 2019
VEHICLE SPEED CONTROL
1 complaint
ON OCTOBER 17, 2018, I DROVE INTO A SHOPPING CENTER PARKING LOT AND PROCEEDED TO PARK IN FRONT OF THE SHOPS. I HAD ENTERED THE PARKING SPACE AT A VERY LOW SPEED AND WAS ALMOST AT A DEAD STOP WHEN MY 2018 FORD FUSION SPORT LURCHED FORWARD WITH SUCH A POWERFUL BURST OF SPEED, I WAS UNABLE TO STOP BEFORE HITTING A WINDOW AND BRICK WALL DIVIDING THE SHOPS. NO FLOOR MAT ISSUE WAS INVOLVED AND I DID NOT STEP ON THE ACCELERATOR THINKING IT WAS THE BRAKE. A POLICE REPORT WAS FILED AND INSURANCE NOTIFIED. THE CAR IS STILL AT FORD DEALER FOR REPAIR. THE COLLISION & SERVICE MANAGER TOLD US THAT NO ERROR COULD BE FOUND WHEN PULLING CODES. THIS IS A MAJOR & DEADLY PROBLEM WITH AUTO SAFETY AND ADVANCED ELECTRICAL SYSTEMS. AN ELECTRONIC GLITCH IN THE THROTTLE CONTROL SYSTEM THAT CANNOT BE DETECTED AFTER ACCIDENT SHOULD BE NUMBER 1 PRIORITY ON AUTO SAFETY !!!! I AM SERIOUSLY AFRAID TO DRIVE MY CAR AFTER REPAIRS BECAUSE LIKE RUSSIAN ROULETTE, IT MAY HAPPEN AGAIN BECAUSE THE PROBLEM DID NOT LEAVE A TRACE THE FIRST TIME. THE NEXT TIME COULD BE AT AN INTERSECTION AND LIVES COULD BE LOST !!!!
Oct 29, 2018
STEERING,UNKNOWN OR OTHER
1 complaint
WHEN THE TEMPERATURE OUTSIDE GOES OVER 70 DEGREES, THERE'S CREAKING NOISES UNDERNEATH, SOMETIMES VERY LOUD WHEN TURNING, EVEN WHEN PARKED, MOVING THE STEERING WHEEL LEFT OR RIGHT IT MAKES THE NOISE. LOOKING ONLINE, THERE ARE SEVERAL COMPLAINTS THAT REPORT THE SAME PROBLEM, MY CAR HAS ONLY 72K MILES AND IT FEELS LIKE SOMETHING IS GOING TO BREAK. IT HAS BEEN HAPPENING ALL SUMMER THIS YEAR AND IT'S GETTING LOUDER. THIS HAS TO BE A RECALL.
Aug 31, 2018
STRUCTURE,LATCHES/LOCKS/LINKAGES
1 complaint
CAR WAS IN MOTION ON A CITY STREET ABOUT 40 MPH GOING STRAIGHT AND ALL OF A SUDDEN THE DRIVER SIDE DOOR BECAME UNLATCHED AND PARTIALLY OPENED. A NOISE ON THE DASH SOUNDED AND STATED THE DRIVERS DOOR WAS AJAR, AND THE LIGHTS ON THE INSIDE OF THE DOOR TURNED RED. IT SEEMED TO BE PARTIALLY LATCHED STILL SINCE IT WOULD NOT OPEN ALL THE WAY, BUT I HAD TO USE THE INSIDE DOOR HANDLE TO OPEN THE DOOR AND THEN CLOSE IT ALL THE WAY AGAIN. I HAD ALREADY TRAVELED ABOUT 1 MILE FROM MY HOME WHEN THE DOOR PARTIALLY OPENED, AND THERE WERE NO DASH OR WARNING SIGNS IT WAS OPEN WHEN I LEFT. TEMPERATURE OUTSIDE WAS CLEAR, NO RAIN OR WIND AND ABOUT 50-55 DEGREES OUTSIDE. CAR WAS PRIOR IN THE GARAGE BEFORE I LEFT ABOUT 1130 PM.
Mar 05, 2018
Where to Find VIN for Problems Check
To check for problems and complaints on your 2018 FORD Fusion, you'll need the VIN number. Find your VIN in one of these 4 common locations.
Understanding VIN Structure for Problem Reports
Each character in your 2018 FORD Fusion 17-digit VIN helps identify specific complaints and problems affecting your vehicle model.
How to Check 2018 FORD Fusion Problems in 3 Steps
1
Locate Your VIN
Find the 17-character VIN on your 2018 FORD Fusion dashboard (visible through windshield), door jamb, engine bay, or vehicle documents.
2
Review by Component
Browse owner-reported complaints organized by vehicle component (engine, transmission, brakes, electrical) to identify common issues and problem patterns for this model year.
3
Check Safety Issues
Review crash and fire incidents for each component to assess safety concerns. Contact your FORD dealer or report problems to NHTSA at SaferCar.gov.
Frequently Asked Questions
How many problems does the 2018 FORD Fusion have?
The 2018 FORD Fusion currently has 397 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.
What are the most common problems with 2018 FORD Fusion?
The most common problems reported for the 2018 FORD Fusion are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.
Where does this 2018 FORD Fusion problem data come from?
All problem and complaint data for the 2018 FORD Fusion comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.
How do I report problems with my 2018 FORD Fusion?
You can report safety problems with your 2018 FORD Fusion directly to NHTSA at SaferCar.gov or call 1-888-327-4236. Your complaint helps identify patterns and may lead to recalls or investigations.
Where can I find my VIN to check problems?
Your 2018 FORD Fusion VIN is located in 4 places: (1) Dashboard near windshield on driver's side, (2) Driver's door jamb sticker, (3) Engine bay, (4) Vehicle registration and insurance documents.
Is the 2018 FORD Fusion reliable?
Reliability can be assessed by reviewing the number and severity of owner complaints for the 2018 FORD Fusion. Check complaints by component, crash reports, and fire incidents above to evaluate potential issues and problem patterns.
Other Years - FORD Fusion Problems
Other FORD Models
'34
1500 Foldaway
A8513
A9513
A9522
Aerostar
Affordable Aluminum
Affordable Trailers
Aspire
AT8513
AT9513
AT9522
Similar Brands
ST
3,555 models
RS
3,484 models
NC
2,822 models
ND
2,385 models
Z
1,951 models
MOTO
1,583 models
NU
1,189 models
RC
1,122 models