2025 KIA K4 Problems & Complaints

Every time I drive my car randomly something sounds like a big pebble hits my windshield. My car is available for inspection upon request. My safety is put at risk cause it scares me(makes me jerk). This can cause me to accidently jerk my steering wheel and cause me to leave my lane & possible hit another vehicle. I have an appointment with the dealership repair center on Nov 9, 2025. I can get it inspected by possibly the police or my insurance agency. There are no warning lamps or messages prior to the sound of a rock hitting my windshield. This sound happens everytime I drive the car since I bought it.

KIA K4 WITH 500 MILES ON IT. EXPERIENCED POPPING NOISE FROM THE WINDSHIELD AS IF A STONE HIT THE WINDSHIELD WHEN CAR WAS NOT IN MOTION. SEEMS TO HAPPEN WHEN THE AC IS ON AND THE SUN IS HITTING THE WINDSHIELD. I HAVE AT LEAST 8 SMALL CHIPS IN THE WINDSHIELD AS A RESULT. I HAVE NOT DRIVEN ANYWHERE THAT HAS AN ABUNDANCE OF ROCKS THAT COULD HAVE CAUSED THIS DAMAGE. IT'S HAPPENED TWICE AT THE SAME EXACT RED LIGHT AT THE SAME TIME OF DAY. I DID REPORT TO KIA CUSTOMER SERVICE AND THEY ASSIGNED A CASE #25559045. THE INSTRUCTED ME TO TAKE IT TO MY DEALER SERVICE DEPT SO THEY CAN SEE THE ISSUES AND HEAR THE NOISE.

I had a diagnostic appointment on 9/8/25 for my 2025 Kia K4 due to a popping noise on the windshield that happens when the weather is hot/sun on windshield. Once the diagnostic was complete, the recommendation from the dealer was to replace the windshield since it was not factory. The dealer did hear the noise during the diagnostic. I purchased the vehicle Jan 2025 and I start hearing the popping noise in June 2025 (factory windshield #1). In August 2025, the windshield was replaced by a company due to what I assumed was a rock hitting my windshield that cause a crack that grew rapidly (windshield #2). The noise continued. My diagnostic results recommended replacing the windshield again. The windshield was replaced again in Sep 2025 (windshield #3). The windshield is still making the same popping noise when out in the sun. From what I've read, this is an ongoing issue with the 2025 Kia K4 vehicles regarding a possible plastic dashboard trim contracting and expanding in the new K4 vehicles.

There is a defect with the WINDSHIELD glass. The windshield glass gives off an audible "SNAP" or "POP" noise when the inside of the windshield glass experiences a stress crack. This is not a crack that can be felt from the inside, or the outside. It is actually inside the glass and it can only be seen when the sun hits the windshield a certain way. Eventually failure of the windshield is imminent. The windshield glass internally fractures under normal driving conditions. It happens commonly, and intermittently, probably at least once per week.

The contact's daughter owns a 2025 Kia K4. The contact stated that there was an abnormal clicking sound coming from the dashboard. Additionally, the contact stated that while his daughter was driving to the dealer, the speedometer displayed 70 MPH; however, the driver was pulled over by the Police and informed the driver that the vehicle was driving 90 MPH. The vehicle was taken to the dealer, where the body domain controller was replaced. The contact stated that while the owner was driving, a week later, the instrument panel and the infotainment system screen turned off. The vehicle was taken to the dealer, where the owner was informed that the vehicle was test-driven every other day to determine the cause of the failure. The owner was provided with vehicle rental assistance. The contact stated that the dealer contacted the owner after 6 weeks and advised that the cause of the failure could not be determined; however, the owner was able to verify through the Mobile App that the dealer had only driven the vehicle twice, and the vehicle failed to exceed 38 MPH while driving. The vehicle was not repaired. The manufacturer was contacted for buy-back assistance, but the request was denied. The contact stated that a local Kia sales advisor stated that a consumer who owned the same vehicle had experienced a similar failure. The failure mileage was approximately 50.

Blind spot and front collision features inactive. Seat belt didn't unlock after crash. Airbags deployed no passenger didn't work on driver airbag b1652 dtc codes on recall for another vehicle

While driving on the freeway in the left lane on a two-lane highway, the lane departure and steer ahead feature incorrectly adjusted steering and pulled vehicle into the right lane. Is incorrect adjustment due to lane departure has happened numerous times. Each time this occurred I was not using copilot features. The lane departure cannot be turned off.

THIS SAME INCIDENT HAD HAPPENED 6 TIMES PRIOR TO MY BEING ABLE TO TAKE A PICTURE OF MY DASHBOARD. THE CRUISE CONTROL CHANGES ON ITS OWN TO 90 OR 110 MPH AND THE ACCELERATION BEGINS ON ITS OWN VERY AGGRESIVELY. IT HAS NOTHING TO DO WITH THE SPEED LIMIT AS YOU WILL SEE ON THE PICTURE, THE SPEED LIMIT IS 65 AND I HAD ALREADY STEPPED ON MY BRAKE TO WHERE MY SPEED WAS THEN 59. I HAVE TAKEN IT FOR SERVICE AT ED MORSE KIA IN SIERRA VISTA, AZ AND THE PROBLEM COULDN'T BE DUPLICATED OR FIXED. I HAVE TOLD THE SALES MGR. AND SERVICE MGR. ABOUT THIS AND LEFT MESSAGES FOR CALL BACK AND HAVE NOT BEEN ACCOMODATED. I AM NOT SAFE IN THIS SITUATION. THEY ARE AWARE THIS IS A PROBLEM FOR OTHER KIA VEHICLES AND THERE IS A GOOGLE SEARCH THAT SHOWS THE SAME CONCERNS (WHICH I HAVE A PICTURE OF AS WELL). AN ADDITIONAL PROBLEM (NOT ASSOCIATED WITH THE INITIAL SAFETY ISSUE, THERE HAVE BEEN SEVERAL TIMES WHERE THE SPEED LIMIT ON MY DASHBOARD HAS CHANGED TO 90 WHEN THE ACTUAL LIMIT IS 45 ETC. MY MAIN CONCERN OF COURSE IS THE SELF ACCELERATION.

Sluggish acceleration, after I got an oil change a few weeks ago. No warning lights whatsoever, I’m thinking it’s the transmission , taking awhile to speed up especially on highway

The airbags failed to go off. I think the vehicle is still available it was towed to Carroll's in Winslow Maine. By the airbags not going off it made the risk of injury much greater. Also lost control of the steering all together. Tried to swerve to miss an animal and the steering assist took over. Yes we have a police report stating that the airbags didn't go off. I am sure budget had their people go look at the car. No warning lights present.

Transmission failure 4 times since purchasing it new in December 2024 I was almost killed multiple times on the highway because car won’t accelerate. Car is jumping when driving and choking Air conditioning shuts off while driving Car gets stuck in park and nothing will work

The contact owns a 2025 Kia K4. The contact stated that after driving for approximately 40 minutes at speeds between 55-75 MPH, the TPMS warning light started flashing, with the message "Check Tire Pressure" displayed. The vehicle was taken to the dealer three times. On the first visit, the dealer was unable to duplicate the issue. On the second visit, the dealer diagnosed the vehicle with an electrical system failure and reprogrammed the TPMS; however, the failure persisted. On the third visit, the dealer was unable to determine the cause of the failure, and the vehicle remained unrepaired. The manufacturer was informed of the failure and opened a case. The failure mileage was approximately 800.

I own a 2025 Kia K4 that has experienced multiple serious defects since purchase, raising ongoing safety concerns. Within the first four months, my windshield has failed or cracked four times, with one replacement denied by Kia and paid out-of-pocket. The windshield continues to make loud cracking noises, suggesting a structural defect that has not been resolved. In addition, the sunroof does not open or close properly, and while Kia acknowledged the defect, they only offered a potential software adjustment that does not address the root cause. The vehicle also makes loud, unpredictable popping noises from the dashboard, a problem that multiple other Kia owners at the same dealership have reported. The dealer confirmed that Kia does not have a fix and only offered to temporarily “push in the dashboard.” Furthermore, the seat cooling system has stopped working entirely without repair options provided. These defects compromise the safety and reliability of the vehicle, creating risks of reduced visibility, potential structural failure, and driver distraction. All issues have been reported and documented at Courtesy Kia of Brandon, FL, and confirmed by the dealer, but Kia has failed to provide adequate remedies. No warning lights or error messages appeared prior to these failures. I have also filed reports with the Better Business Bureau Auto Line, the Florida Attorney General’s Office, and Kia Customer Care, but no meaningful resolution has been provided. These ongoing unresolved defects indicate systemic safety issues with the Kia K4.

Bought my Kia k4 2025 in February at DTLA Kia and the experience has been [XXX]. The first day driving I went up near dodgers stadium , immediately had a burnt smell. I disregarded it thinking maybe its fresh paint burning , WRONG. Till this day 4 months later my tail pipe throws a musty smell. Issue number 2 , the hesitant gas pedal. Who knows what it is maybe fuel system , transmission but daily and I mean DAILY my accelaration is poor,jerky, struggling and overall doesn't work. It has its good mornings but once I'm on the road for more than 10 minutes its back to the struggle. I've had my K4 serviced twice at Dtla service, they never once test drove the car because I was tracking the GPS almost all day for the three days they had it. Once I got my car back it tooks about 45 minutes the service advisor Jeffery Montoya was so lost on where my car was, I had to ask and ask and ask finally the guys who are out front welcoming you helped me and brought my car. That was my decision to never go back to DTLA service. Next took it to Van Nuys Kia waited to weeks from my appointment because they are moving. Finally they kept it for three days they still werent able to diagnose the issue and repair it. Modesto the advisor there said " we can't duplicate the issue''. Some how they made me pay $82 because they supposedly found plastic bags stuck to my exhuast. [XXX] I even told him I don't want it cleaned and he said oh well you authorized the diag so you have to. He reported that info to kia Corp which got my case closed and said the car works fine. NO it does not work fine. Never going. Now today [XXX] I was parking arriving somewhere the k4 said engine off shift to P while ringing the alarm from the dash. I have it on film. Second driving down [XXX] and boom car engine shuts off while car are behind me. I had to shift to p then turn the car off. Turned it back on while getting honked at and that was that. $700 a month for a lack of urgency to help me. Boo Kia. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owned a 2025 Kia K4. The contact stated while driving at various speeds, the vehicle was pulling to the left unintendedly. The contact stated that upon disengaging the Lane Keep Assist, the failure recurred while driving. The vehicle was taken to Discount Tire, where the tire pressure was adjusted. The vehicle was taken to the dealer, where an alignment was performed; however, the failure persisted. The contact stated while exiting the expressway and driving approximately 30 MPH, the vehicle veered to the left unintendedly, causing the contact to lose control of the vehicle. The vehicle veered off the road and crashed into a ditch, and the vehicle faced oncoming traffic. Several unknown warning lights were illuminated after the crash. The air bags did not deploy. The contact hit the middle of her forehead against the steering wheel and sustained a bruise. The contact did not seek medical assistance. The contact was able to exit the vehicle. No police report was filed. There was no property damage. The vehicle was towed to a tow lot. The vehicle was then towed to a second dealer autobody repair shop, Glassman Collision Center (22250 Telegraph Rd, Southfield, MI 48033), where the contact was informed that the driver's side of the vehicle and the transmission were damaged. The vehicle was totaled. The dealer and the manufacturer were notified of the failure. The manufacturer informed the contact that a complaint had been sent to the dealer, and that she would be contacted by the dealer. The failure mileage was approximately 1,300.