2016 KIA Rio Problems & Complaints
Real owner complaints and problems reported to the National Highway Traffic Safety Administration (NHTSA). View common issues by component.
75
Complaints Reported
Complaints by Component
ENGINE
19 complaints
My car is experiencing excessive oil consumption. Upon inspection, it was determined that the issue lies with my catalytic converter. I have discovered that this problem has been reported in other Kia vehicles. The information I found suggests that the oil I am using is being bypassed by the catalytic converter, which indicates a potential issue with the Kia car’s design. Engine light won’t go off
Nov 22, 2025
I got an oil change right after the car overheated and I believe the engine is blown now. I don’t understand how all this can happen after an oils change.
Dec 05, 2024
Vehicle burning through excessive amounts of oil. Check engine light came on and car was making a loud ticking noise and knock. Dealership confirmed the vehicle will need a new engine. Kia Corporate denied replacement because vehicle is out of warranty. Reported problem to Kia before warranty expired and was still denied.
Jul 13, 2024
KIA has failed to remedy the HECU Engine Compartment Fire recall (NHTSA campaign number 23V652000) in a timely manner. The issue has been known since September 2023, Vehicle owners were notified in November, and no further information has been given on the status of the recall. *NOTE* Apologies if this is not the correct form. The recall notice mentions a form where recall issues can be reported but there is no information on where to find it.
Jan 24, 2024
Was told that my car was consuming too much oil and I’ve been doing oil consumption test for the past year I even did the chemical that was run through my motor which I had to pay for and it was over $800 I feel like they’re giving me the runaround one of the employees at Dick Hanna Kia also told me at one point that I could actually replace the motor myself but my car is still under warranty at 92,000 miles. I just want it resolved either they replaced my motor or do something I have two more oil consumption test and then at that point they will send the information to Dick Hanna Kia dealerships or wherever they send it and then tell me what to do next actually getting frustrated. I have to go every 1000 miles and it takes time out of my day to do this.
Dec 29, 2023
+ 14 more complaints for this component
SERVICE BRAKES, HYDRAULIC
11 complaints
The contact owns a 2016 Kia Rio. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Apr 23, 2024
The contact owns a 2016 Kia Rio. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Apr 17, 2024
The contact owns a 2016 Kia Rio. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Apr 17, 2024
The contact owns a 2016 Kia Rio. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Apr 11, 2024
The contact owns a 2016 Kia Rio. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Apr 03, 2024
+ 6 more complaints for this component
UNKNOWN OR OTHER
7 complaints
A recall notice (NHTSA recall # 23V652) was issued on 14Nov23 where the HECU may experience an electrical short circuit, which in turn can result in a car fire. To this date, the remedy part is not available. If I'm not mistaken, car fires can be a serious issue, therefore, I am reporting the delay in availability of this part. I also want to inform you that the telephone number referenced on this website and the recall notice to file a complaint (888-327-4236) is invalid and that this website and number should be updated with the correct phone number.
Jan 15, 2024
Hydraulic electronic control
Nov 18, 2023
Trunk will not close. This happened in 2017 and the car was repaired under warranty. It happened again yesterday. Kia has an active recall on some vehicles for this issue mine is not included...however it is the EXACT same issue. I live in Florida and the recall is an issue with heat damaging the safety latch. Kia needs to extend the recall to cover ALL impacted vehicles.
Dec 13, 2022
The trunk of my car will not open. Upon further inspection, the trunk latch is broken. When we accessed the trunk from the back seats, we tried to open it with the emergency release and it does not work. Nothing opens the trunk. This is a KNOWN issue to Kia and they've recalled other years, but not 2016. So I guess if a person were to get locked in the trunk of a 2016 Rio, it's somehow not a safety issue, even though it is one in later years??
Oct 23, 2022
The trunk latch is broken and does not open with safety latch. Why is my car not on the list for the recall on this particular problem?
Oct 22, 2021
+ 2 more complaints for this component
UNKNOWN OR OTHER,ENGINE
4 complaints
My car is consuming a lot of oil and I have to add it on a weekly basis. The catalytic converter has already been replace once and is on the verge of having to be replaced again because of this issue. I just bought the vehicle last year. I see that there was a previous campaign with this same issue. See campaign NHTSA ID: 23V-652000. I am wondering why my vehicle was not part of it. Please advise next steps to remedy this safety issue on the 2018 KIA Rio models.
Mar 14, 2025
This vehicle is burning oil at an alarming rate: at least 1 quart per tank of gas, approximately 340 miles. No oil light comes on in the dash, even if the engine gets ran to dry. Kia accepts this and claims the vehicle is fine. Even with extended warranty coverage, I’m on month 8 now of trying to get this car fixed with Kia shops and now the catalytic converter is failing. Finally the car has displayed its first check engine code.
Jan 27, 2025
I was parked in ghe parking lot and went into the store and came back to my car and starting then it was not getting started i tried many times even though it was like battery dead and i call my insurance company and asked for roadside assistance amd they tried using jump start evne though it was not starting so with the help of other sources i tried to rotate crankshaft manually it was stucked and not rotating so i thought it was engine sezied.
Jun 17, 2024
AT 148,000 MILES ON THE FREEWAY THE GAS PEDAL WOULD NOT GIVE ANY POWER, STILL RUNNING BUT WOULD NOT GO, STALLED A FEW TIMES. HAD TO PULL OVER AND WAIT, RESTART AND GO A FEW MILES, PULL OVER AND WAIT, THEN GO, ETC. COME TO FIND OUT THERE WAS NOT A DROP OF OIL LEFT. AFTER REPLENISHING, STILL HAD ISSUES, THEN NOTICED THE ANTI-FREEZE WAS LOW. REPLENISHED IS NOW DRIVABLE BUT CONTINUES TO BURN OIL. NO LEAKING & I CHANGED THE PCV VALVE WITH NO RESULTS. I'M STILL ADDING CLOSE TO A QUART OF OIL EVERYDAY. HAVE REASON TO BELIEVE THE PISTON RINGS AND VALVES ARE SHOT AND OIL IS CIRCULATING THROUGHOUT/INTO CYLINDERS. NOW IT'S ON ITS LAST LEG, 152,000 MILES. IT'S BEEN A GOOD RIDE BUT TIME TO GO. NOTE* A/C STOPPED WORKING AT 66,000 MILES *TR
Jun 11, 2020
ENGINE AND ENGINE COOLING
3 complaints
The contact owns a 2016 Kia Rio. The contact stated that while inspecting the vehicle, it was discovered that there was no oil on the dipstick. The vehicle was taken to the local dealer, who was unable to determine the cause of the failure. An oil consumption test was performed; however, the failure persisted. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 50,000.
Sep 29, 2025
The contact owns a 2016 Kia Rio. The contact stated that upon driving from a complete stop, the vehicle failed to exceed 2-3 MPH. There was no warning light illuminated. The contact was able to drive to the residence. The Ford dealer where the vehicle was purchased arranged for the vehicle to be picked up at the residence. The Ford dealer informed the contact that the mechanic and the Kia dealer where the vehicle was taken could not determine the cause of the failure. The contact then took the vehicle to an independent mechanic, where it was determined that the catalytic converter was clogged and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 126,000.
Sep 24, 2025
The contact owns a 2016 Kia Rio. The contact stated while driving approximately 35 MPH, the check engine warning light illuminated. The contact stated that the vehicle had an abnormal burning oil odor in the cabin of the vehicle. The contact drove the vehicle to an independent mechanic who checked the vehicle and determined that the spark plugs needed to be replaced. The vehicle was repaired. The contact stated that the check engine warning light illuminated again. The contact drove the vehicle back to another independent mechanic who checked the engine and determined that engine oil needed to be added. The vehicle was repaired. The mechanic informed the contact to check the oil level every week. The contact stated was adding a quart or more of engine oil every two weeks. The manufacturer was informed of the failure. The failure mileage was approximately 110,000.
May 20, 2024
AIR BAGS
3 complaints
Airbags didn’t deploy in a accident which caused whiplash
Nov 14, 2022
ON NOVEMBER 18, 2018 AT APPROXIMATELY 6:30PM, I WAS INVOLVED IN A CAR ACCIDENT WHERE I REAR ENDED A CAR IN FRONT OF ME WHILE MOVING AROUND 30 MPH IN THE MERGING RAMP OF HWY 57 TO HWY 210 NEAR SAN DIMAS, CA AND I FILED A POLICE REPORT. THE AIRBAG DID NOT INFLATE/DEPLOY.
Nov 30, 2018
ON SEPTEMBER 16, 2016 AT APPROXIMATELY9:12PM, I [XXX] , HAD JUST PICKED UP A PASSENGER WAS INVOLVED IN A CAR ACCIDENT . WHERE AS I WAS REAR ENDED WHILE AT A COMPLETE STOP AT A SIGNAL LIGHT AT THE INTERSECTION OF SOUTHWESTERN AND MOCKINGBIRD WITH THE PASSENGER IN THE CAR. THERE WAS A POLICE REPORT FILED THE NUMBER IS [XXX] THE AIRBAG DID NOT DEPLORE .....UPDATED 10/26/16 *BF INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Oct 08, 2016
ELECTRICAL SYSTEM,ENGINE
2 complaints
The car would constantly stall, would need to jiggle ignition to get car to turn over. burn oil EXTREMELY. would foul spark plugs around 20k-30kmiles. , coolant would get burned and get shot out to the exhaust area, and finally the car would have smoke coming out of the engine bay after driving for a distance of 15-30 miles while also getting terrible MPG. Car on average should get 38mpg highway and 27mpg city. This car was getting about 20-22mpg highway and 16-20mpg city.
May 16, 2024
I stayed on top of oil changes and engine continued to burn an excessive amount of oil in between oil changes. No leak was found after having 3 different inspections. I was told this is a common problem with Kia engines from multiple Kia owners, mechanics, and oil change technicians. Despite this, I made sure I always had oil in it and kept up with the changes. Suddenly, while driving on the interstate, the engine completely failed. I had it towed to a mechanic where it was determined internal engine failure if some sort. My car only had 83,000 miles on it when this happened. Due to me being the second owner, ( I bought the cat at 14,000 miles) I was unable to receive the 100,000 miles power train warranty. I called my local Kia dealership to see if there was anything they could do and was told “engines fail all the time” and that there is nothing they can do.Replacing the engine is more than the car is worth. For the engine to fail out of nowhere with no warning (this was the first time any sort of light came on my dash) after spending time and money on upkeep, is unacceptable. It is also completely unsafe. After some researching, I see that this is a very common issue with kia engines and Kia failed to notify me about obsessive oil consumption and the their faulty motors. Over $400 dollars in mechanic fees and over $300 in towing fees to determine all of this and I am out of a car. Getting a new engine or even fixing whatever internal component it is would be way more than what my car is worth with it running.
Jan 26, 2024
EXTERIOR LIGHTING
2 complaints
When i purchased this vehicle, I had to replace all 4 rear led tail lights. Now 2 years later I have to replace the right rear led side tail light. These led lights should not be going out this soon. Why can't Kia recall this part. This is a safety issue that i should not be replacing this soon.
Nov 18, 2023
WHEN HAEDLIGHTS ARE ON AUTOMATIC AND TURN ON TURN SIGNAL AND MAKE TURN WHEN TURN SIGNAL GOES OFF AFTER MAKING TURN IT TURNS OFF HEAD LIGHTS WHEN MOVING
Jun 17, 2019
POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM
2 complaints
on 08.30.22 while driving on the interstate I75 going approx. 75 mph my vehicle just lost speed and I barely made it to the side of the road. it did not shut off just had no power, this was at 63,000 miles and had to have the catalytic converter replaced. total cost $1800. fast forward to 12.10.22 same thing happened and was told once again need a new catalytic converter. also have had all maintenance done and this GDI engine burns approx. 1 quart of oil every 2 weeks. also make not that the engine light never came on with either event
Dec 13, 2022
TL* THE CONTACT OWNS A 2016 KIA RIO. WHEN THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE FAILED TO ACCELERATE, BUT THE ENGINE CONTINUED TO OPERATE. THERE WERE NO WARNING INDICATORS ILLUMINATED BEFORE OR AFTER THE FAILURE. THE FAILURE WAS EXPERIENCED NUMEROUS TIMES WHILE AT A STOP OR TRAFFIC LIGHT. THE ACCELERATOR PEDAL HAD TO BE DEPRESSED SEVERAL TIMES TO ACCELERATE. THE VEHICLE WAS TAKEN TO TEAM KIA (1215 SCALP AVENUE, JOHNSTOWN, PA 15904, 814-266-8611) WHERE THE DEALER TEST DROVE THE VEHICLE; HOWEVER, THE FAILURE WAS UNABLE TO BE DUPLICATED. THE VEHICLE WAS DIAGNOSED, BUT A FAILURE CODE WAS NOT LOCATED. THE DEALER DETERMINED THAT THE FAILURE OCCURRED DUE TO LOW GRADE FUEL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 915.
Apr 04, 2018
UNKNOWN OR OTHER,ENGINE,FUEL/PROPULSION SYSTEM
2 complaints
On June 29, 2022, I was driving on I-5 southbound when I heard a loud sort of tapping sound coming from my engine. About 30 minutes later, before I had time to get to a gas station, there was a loud "BOOM!" sound and all of a sudden, the catalytic converter light and some other dash lights started to flash and I started to lose power. I pulled over to the left shoulder of the highway and before I could even pop the hood, I noticed flames immediately licking from the underside of the hood. I grabbed my phone and pulled my rabbit in her cage from the back seat of the car and called 911. My car continued to burn, starting a small brush fire, until the fire department finally came and put the fire out. The whole front of my car was completely incinerated and it had made its way to the back hatch in less than hour. I don't know for certain what caused this as the only indication of a problem was the loud tapping sound- zero dash lights were flashing until the boom. I had just taken the car in for an oil change and general check up less than a week before, and they saw nothing amiss. Geico, my insurance company, has inspected it to determine that it is, in fact, a total loss, but I'm sure they didn't do a sort of diagnostic to determine what happened to cause the incident. I am beyond lucky that I was able to escape my car with my pet and my life, but had the fire moved any faster through the car, we would be dead. It all happened within an hour.
Jul 13, 2022
On May 29th 2021 my 2016 Kia Rio engine caught on fire after multiple attempts of letting Kia know that my engine had a possible recall/detect. I was told that my car wasn’t apart of the recall list of considered on the list of the 1.6 million or billion others who’s engines have blown up as well. I have paper work/trail of recent mechanical work/mechanics informing me with “possible recall issues as well”. Paid for an oil change May 21st, visited the mechanic and 8 days later my car was in flames at an EXXON gas station pump, literally traumatized.
Jun 21, 2021
ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE
1 complaint
I was driving when my Kia stalled and shut off but was still playing music and driving. So I pulled over and then my Kia caught on fire and went up in flames.
Jun 26, 2025
VISIBILITY
1 complaint
The contact owns a 2016 Kia Rio. The contact stated while driving at various speeds, the interior rearview center mirror failed to remain in place after manually being positioned. The local dealer was contacted; however, the contact was informed that the warranty had expired after 5 years from the manufactured date. The vehicle was not repaired due to the cost. The manufacturer was made aware of the failure. The failure mileage was approximately 25,000.
Nov 13, 2024
STEERING,SERVICE BRAKES,ENGINE
1 complaint
What component or system failed or malfunctioned, and is it available for inspection upon request? Complete engine lockup during operation at speed which caused steering and braking to be greatly hampered. How was your safety or the safety of others put at risk? The engine failed on a 4-lane highway in traffic which could have easily caused a high-speed accident since the car extremely decelerated and lost power steering and braking in order to get out of traffic. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes confirmed by an independent service center which told me it was either a cylinder rod or a lower engine bearing failure. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No, the manufacture KIA has a recall on other models in this year range but not the RIO. The other models have a similar engine failure caused by a faulty cylinder rod bearing. The RIO has never been added to this recall list, but it should be because it looks like the engine issues are also on this model in the same time frame. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, they only came on when the engine failed. Then every warning light appeared.
Jul 12, 2024
SERVICE BRAKES
1 complaint
We were doing a lot of stop and go driving in warm weather. I noticed braking seemed to be normal at first but just before the accident I press the brake and the pedal went to the floor and the vehicle wouldn’t . I hit the car in front of me. My vehicle was presumably totaled. There was lots of fluids on the floor.
Jun 06, 2024
ELECTRICAL SYSTEM,SERVICE BRAKES
1 complaint
The HECu fuse recall has been over six months with no remedy. I called NHTSA two weeks ago and was told by a representative that the manufacturers (both Kia and Hyundai) stated that the remedy would be posted, and available at the dealerships by the end of last month (March). I would like to escalate my complaint. This is a serious safety concern, and on top of that my vehicle is now more likely to be stolen since it must be kept outside (Kia Boys). I'm a fairly patient person, but this has really gotten me sideways. If you could let me know how I can formally file a complaint I would appreciate it.
Apr 01, 2024
STEERING,SERVICE BRAKES, AIR
1 complaint
The contact owns a 2016 Kia RIO LX . The contact stated while driving 15 MPH, the contact could not see and it was difficult to steer the wheel causing the vehicle to slide into a ditch. The contact stated the Tire Pressure Monitoring System and Anti-lock Brake light was illuminated. The contact was able to drive the vehicle out of the ditch to the residence and later to the dealer. There was no physical injuries, however the contact sustain emotional trauma. The police was not called. The dealer stated the Steering Angle Sensor had a dtc1259 code . The vehicle was repaired, replacing the subframe and the control driver front lower control arm. The manufacturer was not made aware of the issue yet. The approximate failure mileage was 45,000.
Jan 26, 2024
SERVICE BRAKES, HYDRAULIC,ENGINE
1 complaint
The contact owns a 2016 Kia Rio. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was made aware of the issue. The contact stated that the check engine warning light was illuminated. The vehicle was not diagnosed or repaired. The approximate failure mileage was 60,000. VIN tool confirms parts not available.
Dec 15, 2023
ELECTRICAL SYSTEM,SERVICE BRAKES,ENGINE
1 complaint
I was driving down the road and suddenly my check engine light starts flashing and the vehicle starts surging. I pull over and shut the car off. I get outside to the hood to open it, as there is steam coming out, and as I put my hand on the hood release, a fire erupts from the engine going over my windshield and driver window. Burning my entire car and $2500 worth of belongings to the ground.
Nov 29, 2023
LATCHES/LOCKS/LINKAGES
1 complaint
My trunk latch wasn't working. I couldn't close my trunk. I contact Kia service and since I still have a platinum warranty with them, asked them if they could repair it free of charge. They said no. So I had to use tape to keep the trunk shut which kept getting wet from the rain while I had to wait for my kia truck latch part to arrive through mail so my husband could install it. I am not sure if this was right before they knew of the issue or not, but I feel like I deserve a refund for the part.
Nov 29, 2023
POWER TRAIN,VEHICLE SPEED CONTROL
1 complaint
The contact owns a 2016 Kia Rio. The contact stated that while attempting to accelerate, the vehicle failed to respond as needed. The accelerator pedal was depressed, but the vehicle was slow to respond. There were no warning lights illuminated. The vehicle was taken to several independent mechanics, who were unable to identify the cause of the failure. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 34,000.
Nov 27, 2023
SERVICE BRAKES,ENGINE
1 complaint
From what I understand kia has no fix for manufacturer recall # SC284UB and NHTSA recall# 23V652. That is unacceptable and unprofessional. Kia is a hugh car dealer and they are saying there is no fix yet! I can't believe kia would put people and families at risk. Kia's action plan to put your car outside and not in your garage , is ridiculous. I was never contacted about this recall, that's unacceptable. Kia needs a fix NOW!
Nov 18, 2023
POWER TRAIN
1 complaint
Ignition getting stuck in acc car can’t go anywhere can’t turn key off steering wheel won’t lock no don’t have money to put in shop arm no hasn’t been inspected no lamps no warning just started doing it has done a few times now
Sep 05, 2023
STRUCTURE
1 complaint
Trunk stopped opening off and on then stopped latching caused me not to be able to see behind me it popped open when was driving and would latch had to tie shut with a. String no don’t have money to put in shop no hasn’t been inspected no no lamps no warnings symptoms
Sep 05, 2023
ELECTRICAL SYSTEM
1 complaint
The contact owns a 2016 Kia Rio. The contact stated that occasionally the key failed to be removed from the ignition switch, and the front driver’s side door. The contact stated no warning light was illuminated. The vehicle was not drivable. The contact towed the vehicle to the local dealer, where the mechanic was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 49,000.
Apr 26, 2023
AIR BAGS,SEAT BELTS
1 complaint
The air bags malfunction they didn’t go off and seatbelt didn’t lock on impact. Yes my safety was at risk. I keep calling them and they not do pick up the phone I get transferred back to the receptionist. The insurance company is doing their inspection the police as well. No warnings.
Jun 13, 2021
POWER TRAIN,UNKNOWN OR OTHER,ENGINE
1 complaint
I HAVE 2016 KIA RIO LX AND I BEEN HAVE PROBLEMS WITH IT FIRST IT WAS MY WIDOW SWITCH KEEP RUBBING SO I TOOK THE THE DEALERSHIP AND THE SAID IT NEEDED OIL ON IT WAS DRYOUT.NEXT I HAVE PROBLEM WITH THE FUEL TANK WHEN I PUMP GAS IN THE TANK IT KEEP REJECTING AND CLICKING AT THE PUMP LIKE IT'S FULL OF GAS AND IS NOT.THEN SOMETHING ON THE DASHBOARD BE POPPING UP EVERY NOW AND AGAIN AND SHOWING THE ESC CONTROL WHEN DRIVING.NOW THE CAR TO START SMOKING WHEN I PULL OFF ONLY AND I KEEP HAVING TO ADD OIL.
Apr 09, 2021
ELECTRICAL SYSTEM,ENGINE,VISIBILITY/WIPER
1 complaint
PROBLEMS: 1) AC STOPS WORKING AND ONLY BLOWS WARM AIR, 2) WINDSHIELD WIPERS DOES NOT WORK. BOTH FRONT AND BACK 3) FRONT LIGHTS DOES NOT WORK
Aug 05, 2019
ELECTRICAL SYSTEM,STRUCTURE,ENGINE
1 complaint
TL* THE CONTACT OWNED A 2016 KIA RIO. A MINUTE AFTER THE CONTACT EXITED THE VEHICLE, IT CAUGHT ON FIRE. THE FIRE DEPARTMENT WAS CALLED AND EXTINGUISHED THE FIRE. THE VEHICLE WAS DESTROYED. THE DEALER (DYER KIA, 21280 US-27, LAKE WALES, FL 33859) WAS CONTACTED AND ADVISED THE CONTACT TO CALL THE MANUFACTURER. THE MANUFACTURER WAS CONTACTED AND WAS UNABLE TO ASSIST. THE VEHICLE WAS NOT DIAGNOSED. THE CAUSE OF THE FIRE WAS UNKNOWN. THE FAILURE MILEAGE WAS 16,003. *LN*JB
Oct 23, 2018
STEERING,ENGINE
1 complaint
THE ISSUE HAS OCCURRED FOUR TIMES SINCE PURCHASING THE CAR AT THE END OF DECEMBER 2017 (LESS THAN 6 MONTHS AGO). THE DASHBOARD WILL LIGHT UP WITH A NUMBER OF ICONS AFTER THE CAR IS TURNED ON (SEE PHOTO FROM DECEMBER). THE FIRST TIME THIS HAPPENED, IT WAS A BITTERLY COLD DAY AND THE ICONS POPPED UP AS I WAS DRIVING. I FELT THE STEERING BECOME TIGHT, BUT LUCKILY I WAS TURNING INTO A PARKING LOT TO SAFETY. THE ICONS WENT AWAY AFTER RUNNING THE CAR FOR A LONG TIME (I WAS TOLD IT WAS JUST THE COLD WEATHER). BUT WHEN I CHECKED ON MY CAR LATER BEFORE DRIVING, THE ICONS RETURNED. I HAD TO GET THE VEHICLE TOWED LATER THAT DAY BECAUSE THE ICONS DID NOT GO AWAY AND THE POWER STEERING DID NOT RETURN. THE ISSUE STOPPED AS SOON AS IT REACHED THE DEALERSHIP, SO THEY SENT ME ON MY WAY. I TURNED THE CAR ON THE FOLLOWING MORNING (STATIONARY, DID NOT MOVE IT YET) AND THE ICONS RETURNED, THE POWER STEERING WAS GONE. I GOT IT TOWED AGAIN. AFTER DAYS OF TESTING, THEY DETERMINED IT WAS AN ISSUE WITH THE ENGINE CONTROL MODULE AND SOMETHING WAS FIXED WITH WIRING. NOW IT IS JUNE 2018, AND THE ISSUE HAPPENED AGAIN (ON A WARM DAY - SO IT IS NOT COLD RELATED AS I WAS ORIGINALLY TOLD). I COULD NOT STEER AFTER TURNING THE VEHICLE ON IN THE EARLY MORNING ONCE AGAIN. I GOT IT TOWED TO THE DEALERSHIP AND THE ISSUE IS BEING INVESTIGATED. I BELIEVE THIS IS A MAJOR SAFETY ISSUE AS THE STEERING IS AFFECTED, AND WITH HOW MANY ICONS LIGHT UP RELATED TO THE AIR BAGS AND BRAKES, I AM NOT SURE WHAT ELSE COULD BE AFFECTED BY THIS ISSUE.
Jun 09, 2018
SUSPENSION
1 complaint
TL* THE CONTACT OWNS A 2016 KIA RIO. WHILE DRIVING 15 MPH AND MAKING A LEFT TURN, AN ABNORMAL SOUND WAS PRESENT. THE CONTACT HEARD SOMETHING DRAGGING IN THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO BOB SIGHT INDEPENDENCE KIA (1700 S. NOLAND ROAD, INDEPENDENCE, MO 64055) WHERE IT WAS DIAGNOSED THAT THE REAR AXLE FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE FAILURE WAS LIKELY CAUSED BY THE OWNER. NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 58,000. THE VIN WAS NOT AVAILABLE.
Oct 23, 2017
Frequently Asked Questions
How many problems does the 2016 KIA Rio have?
The 2016 KIA Rio currently has 75 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.
What are the most common problems with 2016 KIA Rio?
The most common problems reported for the 2016 KIA Rio are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.
Where does this 2016 KIA Rio problem data come from?
All problem and complaint data for the 2016 KIA Rio comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.
Other Years - KIA Rio
2023 Problems
2022 Problems
2021 Problems
2020 Problems
2019 Problems
2018 Problems
2017 Problems
2015 Problems
2014 Problems
2013 Problems
2012 Problems
2011 Problems
2010 Problems
2009 Problems
2008 Problems
2007 Problems
2006 Problems
2005 Problems
Other KIA Models
Similar Brands
ST
3,555 models
RS
3,484 models
NC
2,822 models
ND
2,385 models
Z
1,951 models
MOTO
1,583 models
NU
1,189 models
RC
1,122 models