2004 KIA Sorento Problems & Complaints
Real owner complaints and problems reported to the National Highway Traffic Safety Administration (NHTSA). View common issues by component.
220
Complaints Reported
Complaints by Component
ENGINE AND ENGINE COOLING
33 complaints
SUMMARY: I WAS DRIVING ALONG THE INTERSTATE AT APROX. 65 MPH. I HEARD A TICKING NOISE AND LOOKED AT THE DASH. NO WARNING LIGHTS MY FRIEND ASKED IF THE CAR FELT LIKE IT WAS LOSING SPEED AND IT WAS I IMMEDIATLY PULLED OVER. MOVING TO THE EMERGENCY LANE THE ENGINE STALLED. NONE OF THE GUAGES INDICATED ANYTHING WRONG , AND EVEN AFTER THE ENGINE FAILED THE ENGINE CHECK LIGHT DOES NOT LIGHT UP, NONE OF THE SAFETY INDICATORS LIGHT UP. THE VEHICLE HAS 75,000 MILES ONLY 13,000 OF WHICH I AM RESPONSIBLE FOR. I AM NOT COVERED UNDER THE WARRANTY BECAUSE I AM NOT THE ORIGINAL OWNER WHICH IS RIDICUALOUS IN ITSELF BECAUSE THE WARRANTY SHOULD COVER MILEAGE AS IT STATES NOT OWNERS. HOWEVER, THIS PROBLEM OCCURRED BECAUSE OF THE FLUID LEAKING OUT OF THE WATER RESERVOIR/OR POSSIBLY A FAILED WATER PUMP THAT KIA KNOWS WILL FAIL. IF KIA WAS AWARE OF THIS PROBLEM AND DID NOT ISSUE A RECALL, KNOWING THAT THIS COULD CAUSE SERIOUS ENGINE PROBLEMS OR DEATH, WHY ARE THEY NOT RESPONSIBLE FOR THIS MOTOR? THE REPAIRS ARE GOING TO COST MORE THAN 5000 DOLLARS THIS SHOULD NOT BE TOLERATED. IF YOU SPEND ANY MONEY ON A VEHICLE, CHANGE THE OIL EVERY 3 TO 5 THOUSAND MILES FOLLOW ALL SAFETY RECALLS, YOU SHOULD EXPECT MORE THAN 75,000 MILES OUT OF IT. KIA SHOULD BE HELD ACCOUNTABLE! I HAVE CONTACTED A LAWYER IN THIS MATTER I BELIEVE THAT KIA KNOWS ITS VEHICLES ARE FAULTY AND ARE WAITING FOR THE COST OF LAWSUITS AGAINST THEM TO INCREASE TO BE MORE THAN THE COST OF A RECALL FOR THIS PROBLEM, BEFORE THEY DO ANYTHING TO RECTIFY THE ISSUES. *TR
Apr 04, 2012
WHILE DRIVING I SUDDENLY HEARD A SOUND COMING FROM MY ENGINE AND SEVERAL DASHBOARD LIGHTS ILLUMINATED. I WAS ABLE TO DRIVE THE CAR TO THE AUTO MECHANIC THAT WORKS ON MY CAR WHO INFORMED ME THAT IT WAS A CRANK PULLEY BOLT THAT HAD SHEARED OFF. THE MECHANIC ALSO INFORMED ME THIS IS A VERY COMMON PROBLEM WITH KIAS. AFTER DOING A LOT OF INTERNET RESEARCH I FOUND OUT THAT THIS IS TRUE. THE CAR HAS 135,000 ON IT. I HAVE SPENT OVER $4,000 ON REPAIRS ON THIS CAR IN THE LAST YEAR. IT SEEMS THAT EVERYTHING DECIDED TO GO THIS YEAR. I ONLY DO HIGHWAY DRIVING AND I AM THE ONLY OWNER. I AM VERY CAREFUL WITH MY CAR. ANY CHANCE KIA WILL REIMBURSE? *TR
Dec 28, 2011
TL* THE CONTACT OWNS A 2004 KIA SORENTO. WHILE DRIVING APPROXIMATELY 35 MPH THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THE CRANK SHAFT PULLEY HAD TO BE REPLACED. AFTER THE VEHICLE WAS REPAIRED THE FAILURE CONTINUED TO OCCUR. THE FAILURE OCCURRED THREE DIFFERENT TIMES. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 47,500.
Sep 28, 2011
TL* THE CONTACT OWNS A 2004 KIA SORENTO. THE CONTACT STATED THAT A LOOSE INDUCT CONTROL VALVE FELL INTO THE ENGINE, CAUSING THE ENGINE TO BECOME DEFECTIVE. THE DEALER AND MANUFACTURER WERE NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 99,648. UPDATED 11/08/11*LJ
Sep 15, 2011
JUST NORMAL DRIVING THE RESERVE RADIATOR TANK SPLIT AT THE SEEM. THE CAR HAS 60,000 MILES ON IT. IT LEAKED ALL OVER IN MY GARAGE AND MY TWO PUPPIES ALMOST LICKED UP THE COOLANT FROM THE FLOOR. *TR
Aug 21, 2011
+ 28 more complaints for this component
ENGINE
21 complaints
THEY HAD A RECALL AND A LAWSUIT ON THE KIA FOR THE PULLEY BOLT KEEPS BREAKING AND I NEVER GOT A NOTICE AND MINE KEEPS BREAKING AND KIA WON'T DO ANYTHING ABOUT IT.
Feb 28, 2019
I HAVE FIXED MY PULLEY BOLT 3 TIME AND IT KEEP BRAKING AND I DON'T KNOW WHAT ELSE TO DO TO FIX THE PROBLEM
Jan 18, 2019
CRANK SHAFT BOLT ISSUES. I AM ON MY 3RD HARMONIC BALANCER AND NOW MY MECHANIC IS SAYING IT IS THE CRANK SHAFT BOLT. . I CALLED A&B KIA AND THEY SAID NO ISSUES . I HAVE RECEIVED A CLAIM LETTER FOR THIS ISSUE AND A&B KIA IS REFUSING TO CORRECT THIS ISSUE.
May 08, 2017
TL* THE CONTACT OWNS A 2004 KIA SORENTO. WHILE STATIONARY, THE VEHICLE CAUGHT FIRE WITHOUT WARNING. THE CONTACT EXTINGUISHED THE FIRE. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 170,000.
Oct 19, 2016
HARMONIC BALANCER PULLEY BOLT BROKE. VERY BAD DESIGN. DRIVING DOWN THE ROAD IT BROKE OFF CAUSING LOSS OF POWER STEERING. BOLT SNAPPED OFF INSIDE CRANKSHAFT.
Sep 04, 2016
+ 16 more complaints for this component
POWER TRAIN
19 complaints
Crank pully bolt snapped. Causing crank pully to fall, and critical belts to fail.
Dec 20, 2021
CRANKSHAFT BOLT BROKE WITH APPROX 75,000 MILES. KIA ISSUED SERVICE BULLETIN AND REPLACED THE BOLT. BUT THE MOTOR WAS DESTROYED WHEN IT BROKE AND CONTINUOUSLY OVERHEATED AND WAS UNDRIVABLE. IT REQUIRED A NEW MOTOR. NOT HAVING $ TO REPLACE MOTOR & KIAS ZERO ACCOUNTABILITY. VEHICLE SAT AT A REPAIR SHOP FOR 2 YEARS & THEY FILED FOR AN ABANDONED TITLE. AT THE TIME VALUED AT APPROX $7500. WASTED!!!! THANKS KIA!
Sep 13, 2016
DRIVING ON INTERSTATE HWY, 70 MPH, THE HARMONIC BALANCE BOLT AND ROLL PIN SHEARED OFF LEAVING BROKEN OFF STUBS IN CRANKSHAFT. CAUSING LOSS OF POWER STEERING, POWER BRAKES, I HAD DEALER REPLACE ALL FAN BELTS BECAUSE OF SQUEALING FOR THE TRIP, 300 MILES BEFORE THE FAILURE. *TR
Nov 26, 2013
WHILE DRIVING ALL WARNING LIGHTS CAME ON AND ALL BELTS BROKE STEERING WOULDN'T WORK. *TR
Jan 26, 2013
CORROSION OF REAR DIFFERENTIAL, BOTH LEFT AND RIGHT ARM COMPLETELY BROKE OFF AXLE ASSY, UNSAFE TO DRIVE. REPAIR SHOP I'VE USED FOR THE LAST 4 YEARS GAVE ESTIMATE OF $1,300.00 WITH POSSIBLE ADDITIONAL COST OF UP TO $500.00. THEY SUGGESTED I CALL KIA REGARDING MY 10 YR. 100,000 MILE WARRANTY. CALLED KIA CORPORATE HEADQUARTERS FOR 10 YR. 100,000 MILE WARRANTY. WAS TOLD I NEEDED TO TOW IT FROM MY REPAIR SHOP TO THE NEAREST KIA DEALER WHICH WAS 48 MILES AWAY. SERVICE MANAGER AFTER LOOKING AT DEFECT TOLD ME WARRANTY DENIED WOULD COST $2,700.00 (APPROXIMATE) AND COULD COUNT ON AN ADDITIONAL $500.00 TO $1,000.00 WHEN TAKEN APART. PLACED ANOTHER CALL TO KIA CORP. HEADQUARTERS FOR WARRANTY AND WAS TOLD THERE IS NO DEFECT. DAMAGE AS A RESULT OF SALT OUT OF THEIR CONTROL, AND THE SERVICE MANAGER HAD THE FINAL SAY. *TR
Jul 09, 2012
+ 14 more complaints for this component
SUSPENSION
14 complaints
2004 KIA SORRENTO 97,000 MILES. THE LEFT AND RIGHT SIDE REAR CONTROL ARM BRACKETS RUSTED OFF.
Jan 10, 2020
TOOK MY CAR IN FOR NYS INSPECTION AND WAS ALERTED TO AN ISSUE WITH MY REAR SUSPENSION. THE REAR CROSS MEMBER IS COMPLETED ROTTED OUT AND THE UPPER TRAILING ARM HAVE BECOME SEPARATED FROM THE CROSS MEMBER DUE TO RUST AND CORROSION. THIS IS A 2004 KIA SORENTO EX THAT I PURCHASED NEW AND NOW HAS 103,000 MILES. THIS CORROSION IS AN EXTREMELY HAZARDOUS SITUATION AND THE VEHICLE CANNOT BE REPAIRED. NEEDLESS TO SAY IT CANNOT BE DRIVEN.
Oct 02, 2018
WAS DRIVING WIFE TO WORK , STOPPED AT LIGHT WHEN LIGHT TURNED GREEN I PUSHED THE GAS PEDAL AND I HEARD A BANG SO LOUD I THOUGHT SOMEONE HIT US FROM BEHIND. I DROVE CAR HOME AND LOOKED UNDER IT AND I COULDN'T BELIEVE IT ! THE RUST ON THE REAR END BRACKETS AND THE TWO BARS CONNECTED TO THEM WERE TOTALLY RUSTED THROUGH AND HANGING OFF. I WENT TO THE KIA DEALER WHERE I ORIGINALLY BOUGHT THE CAR AND ASKED THEM ABOUT IT THEY SAID THEY NEVER HEARD OF THAT PROBLEM. I TOLD THEM THERE ARE HUNDREDS OF COMPLAINTS ON THE INTERNET ABOUT IT ,THEY TOLD ME DON'T BELIEVE EVERYTHING YOU SEE ON THE INTERNET. THEN THEY SAID THAT IT'S NOT A KIA PROBLEM IT'S A ROAD SALT PROBLEM. I TOLD THEM NOTHING ELSE UNDER THE CAR WAS RUSTED THAT BAD , AND I BELIEVE IT'S A DESIGN PROBLEM. THEY SAID THERE IS NOTHING THEY CAN DO, SO NOW I HAVE A CAR WITH ONLY 83,000 MILES ON IT THAT IS TOO DANGEROUS TO DRIVE. THIS PROBLEM HAD TO HAVE STARTED WAY WAY BEFORE 83,000 MILES TO HAVE GOTTEN THIS BAD.
Jun 23, 2018
MY DAUGHTER TOOK MY CAR A 2004 KIA SORENTO IN FOR A NYSI AND THE SHOP DEAD LINED THE CAR AND MADE ME FLATBED IT HOME DUE TO THE FACT THAT THE REAR END WAS FALLING OUT DUE TO EXCESSIVE ROT ON THE BRACKETS AND THEY DEEMED THE CAR UNSAFE TO DRIVE. THE WOMEN THAT RUNS THE SHOP TOLD MY DAUGHTER AND SON THAT THIS ISN'T THE FIRST TIME THAT SHE HAS SEEN THIS ON A KIA. IN FACT ITS A PREVALENT ISSUE! UPON COMING HOME I DID SOME RESEARCH ON THE INTERNET AND FOUND THAT THIS IS A MAJOR ISSUE THAT THE FEDERAL GOVERNMENT SHOULD BE LOOKING INTO ORDERING KIA TO DO A RECALL,MY DAUGHTER COULD HAVE BEEN KILLED DRIVING THIS VEHICLE.I ALSO SAW ON THE INTERNET THAT IN THE UK KIA HAD TAKEN CARE OF THIS ISSUE WITH CONSUMERS. I WOULD LIKE CONSIDERATION IN HAVING KIA REPAIR THIS CAR FREE OR PURCHACE THE VEHICLE BACK AT BLUE BOOK PRICING. THIS IS AN EXTREMELY DANGEROUS ISSUE THAT COULD HAVE KILLED MY DAUGHTER OR ANYONE ELSE ON THE ROAD WHERE MY DAUGHTER WAS DRIVING THE KIA SORENTO.
Feb 05, 2018
THE REAR AXLE IS FALLING APART AND IT'S RUSTED WHERE I CAN'T EVEN WELD A BRACKET FOR THE REAR SUSPENSION IT'S SO RUSTED THAT I WAS TOLD BY A MECHANIC THAT THE REAR AXLE CAN ACTUALLY FALL OFF THE VEHICLE I WOULD HAVE TO REPLACE THE ENTIRE REAR AXLE SO I CAN PUT A BRACKET OR IT WILL COME WITH A BRACKET IT WILL COST ME $4000 AND I THINK A KIA SHOULD BE RESPONSIBLE BECAUSE THE WHOLE ENTIRE CAR UNDERNEATH IT RUSTED BUCKET FULL OF RUST
Sep 17, 2017
+ 9 more complaints for this component
STRUCTURE
13 complaints
THIS KIA WAS HOUSED AND STORED IN A GARAGE FOR MOST OF ITS LIFE AND DRIVEN ONLY IN THE SUMMER. IN THE WINTERS OF MICHIGAN IS WAS HOUSED IN A CLEAN DRY GARAGE. THIS KIA WAS A 2 OWNER CAR. I AM THE SECOND OWNER. I HAD DRIVEN IT ONE WINTER AND THIS SUMMER TOOK IT TO GET AN ALIGNMENT BECAUSE IT PULLED TO THE RIGHT. ALIGNMENT CENTER COULD NOT DO THE ALIGNMENT BECAUSE THE WHOLE RIGHT DRIVERSIDE OF THE FRAME WAS RUSTED OUT BEYOND THEIR SAFTY STANDARDS. THE KIA WAS PULLING TO THE RIGHT BECAUSE THE WHOLE FRAME ON THE RIGHT SIDE WAS 80% RUSTED OUT AND THE LEFT SIDE WAS ALSO BUT NOT TO THE EXTENT OF THE RIGHT SIDE. THERE ARE FOOT LONG GAPING HOLES IN THE FRAME DUE TO THE RUSTING. IT IS IRREPARABLE. THERE IS NO SAFE SPOT TO WELD TO TO FIX IT EITHER. AFTER A RAIN I NOTICED THE POOLS OF WATER GO DIRECTLY UNDER THE KIA INSTEAD OF ON THE SIDES POOLING AND DRIPPING OFF THE FRAME ON EACH RIGHT AND LEFT SIDE. A FLAW OF DESIGN BUT A DEADLY IF TRAVELLING AND THE CAR SNAPS IN HALF. THE KIA LOOKS PERFECT AND RUNS PERFECT. THE UNDERSIDE IT'S FRAME IS TOTALLY RUSTED BEYOND REPAIR. KEPT IN A GARAGE AND OUT OF ELEMENTS FOR VIRTUALLY ALL OF ITS LIFE, THIS SHOULD NOT HAVE HAPPENED. DEFECTIVE STEEL ? DEFECTIVE BODY DESIGN? DEFECTIVE KIA. NOT SAFE NOT DRIVABLE.
Aug 25, 2020
WHOLE DRIVING DOWN ROAD STARTED TO LOOSE CONTROL. UPON BRINGING TO A SERVICE STATION FOUND OUT REAR FRAME OF VEHICLE IS COMPLETELY ROTTED AWAY LEAVING SUSPENSION HANGING AND NOT DRIVABLE.
Oct 10, 2016
EXCESSIVE RUST TO THE FRAME. IT IS SO BAD NOW YOU CAN POKE HOLES IN THE FRAME WITH YOUR FINGER. IF IT IS THIS BAD NOW IT WAS ALREADY RUSTED BADLY AT OR BEFORE 10 YEARS OLD.
Jul 06, 2016
TL* THE CONTACT OWNS A 2004 KIA SORENTO. WHILE THE VEHICLE WAS STATIONARY, THE REAR FRAME THAT CONNECTED THE ROTARY BAR WAS SEVERELY RUSTED AND CORRODED. THE FAILURE CAUSED THE VEHICLE TO BECOME UNSTABLE. THE VEHICLE WAS NOT REPAIRED THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 78,000. UPDATED 03/07/17*LJ CONSUMER STATED VEHICLE WAS FIXED UPDATED 6/20/18*JB
Jun 24, 2016
TL* THE CONTACT OWNS A 2004 KIA SORENTO. THE CONTACT STATED THAT WHILE IN PARK, THE CONTACT NOTICED THAT THE REAR SUB FRAME HAD CORRODED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 82,000.
Mar 31, 2016
+ 8 more complaints for this component
AIR BAGS
9 complaints
TAKATA RECALL AIR BAG LIGHT IS ON THE DASH CAN I GET THIS REPLACED FOR NO CHARGE LIGHT STAYS ON ALL THE TIME.
Aug 29, 2019
MY AIR BAG LIGHT TURNED ON. IT TURNED ON JUST UNDER A 100,000 MILES. I LOOKED AROUND ON LINE AND ALOT OF PEOPLE ARE COMPLAININF ABOUT THIS SAME ISSUE WITH THE SAME MAKE AND YEAR. IT WILL NOT PASS INSPECTION BECAUSE OF IT AND THAT IT WILL COST ME AT LEAST $200 TO FIX IT.
Nov 27, 2015
TL* THE CONTACT OWNS A 2004 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, ANOTHER VEHICLE CRASHED INTO THE CONTACT'S VEHICLE. THE VEHICLE WAS FLIPPED BY THE FORCE OF THE IMPACT. THE FRONT AND SIDE AIR BAGS FAILED TO DEPLOY. THE DRIVER SUSTAINED INJURIES TO THE BACK, NECK, HIPS AND EYES. THE FRONT PASSENGER SUSTAINED A HEAD CONTUSION, INJURIES TO THE SHOULDER, HIPS, LEGS AND BACK, IN ADDITION TO INTERNAL BRUISING. ADDITIONALLY, THERE WERE THREE SMALL CHILDREN WHO WERE SEATED IN THE REAR THAT SUSTAINED HEAD INJURIES AND ABRASIONS. A POLICE REPORT WAS FILED OF THE INCIDENT. THE VEHICLE WAS NEITHER DIAGNOSED NOR REPAIRED TO DETERMINE THE CAUSE OF THE AIR BAG FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.
Mar 31, 2014
WHILE APPROACHING TO AN INTERSECTION THE KIA CRASH THE FRONT LEFT SIDE TO THE BACK OF A LAND ROVER, AND DESPITE THE BIG IMPACT AND DAMAGES THE AIR BAGS DIDN'T OPENED ENDANGERED THE LIFE OF MY DAUGHTER. I HAVE PHOTOS OF THE BIG IMPACT AS OF THE FACT THAT THE AIR BAGS DIDN'T OPENED.
Aug 28, 2011
2004 KIA SORENTO. ROLLOVER. KIA SAYS THAT THE AIR BAGS ARE TURNED OFF IN A ROLL OVER NOT WHEN HIT ON THE SIDE! WHAT GOOD ARE THEY THAN? THIS INFORMATION IS NOT GIVEN WHEN THE KIAS ARE PURCHASED.... RESEARCH NEEDS TO BE DONE FOR HOW OFTEN IT OCCURS AND THAT THERE MAY BE MORE ROLLOVERS THAN SIDE IMPATCTS, WHY THEY ROLLOVER SOO MANY TIMES, AND THAT THERE ARE MANY COMPLAINTS FOR OTHER KIAS THAT THE AIRBAGS HAVE NOT DEPLOYED IN CRASHES. CONSEQUENCES WERE THAT THE DRIVER DIED THIS TIME DUE TO THE AIR BAGS DID NOT DEPLOY! THERE WAS ONLY ONE PERSON THE DRIVER IN THE KIA, THE CRASH WAS WHEN THE VEHICLE HIT THE ROCK AND THAN THE GROUND 15 TIMES. *TR
Sep 17, 2010
+ 4 more complaints for this component
ELECTRICAL SYSTEM
7 complaints
THE ELECTRICAL SYSTEM GOES HAYWIRE. WE WILL BE DRIVING ALONG AND THE INTERIOR LIGHTS COME ON, THE FRONT DOORS OPEN LIGHTS COME ON AND STARTS BUZZING AND SO DOES THE THE LOCKING MECHANISM ON THE DOORS. WE CHECK TO MAKE SURE THE DOORS ARE CLOSED PROPERLY BUT THEY ALWAYS ARE. THIS IS WHEN THE CAR IS IN MOTION USUALLY BUT SOMETIMES WHILE STATIONARY AS WELL. SOMETIMES THE DOORS UNLOCK TOO. WE HAVE NO IDEA WHAT CAUSED THIS BUT FEEL IT IS A SAFETY HAZARD AS WELL AS A NUISANCE WHILE DRIVING. IT NEVER SEEMS TO MATTER IF YOU ARE DRIVING STRAIGHT OR TURNING.. WE HAVEN'T TAKEN IT ANYWHERE FOR REPAIRS YET, BECAUSE IT SEEMS TO BE ELECTRICAL AND KNOW THAT IT CAN BE EXPENSIVE.
Feb 13, 2018
FAN RELAY SENSOR IS FAULTY. ALL THE ELECTRICAL SYSTEM IS IS QUESTIONABLE, FROM HEADLIGHTS ALWAYS NEEDING REPLACEMENT TO DASH LIGHTS THAT TURN ON OR OFF AT ANY GIVEN TIME. MY NEWEST ISSUE IS WITH THE HEATER, IT WILL ONLY BLOW WARMED AIR IF THE MOTOR IS BEING REV'D..TEMP IS WARM ON ENGINE BUT IF I AM DRIVING DOWN HILL, IT WILL FEEL LIKE AIR CONDITIONER INSTEAD. FOR A FEW MONTHS MY DRIVER SIDE DOOR WOULD OPEN FROM INSIDE ONLY. MAGICALLY IT HAS RESOLVED THAT ONE AND ONLY ISSUE... *TR
Feb 16, 2015
FEBRUARY 21, 2013 LOS ANGELES, CA ELECTRICAL I BOUGHT MY KIA BRAND NEW. I HAVE HAD SEVERAL PROBLEMS: COMPLAINT 1: I AM WRITING THIS COMPLAINT AGAINST KIA MOTORS WHO WILLINGLY KNOWS OF ISSUES WITH ITS FUEL SYSTEMS IN ALL 2004 KIA SORENTOS. EVEN LOOKING ONLINE YOU SEE THOUSANDS OF KIA OWNERS WHO HAVE HAD THE SENSOR GO OUT ON THIS MODEL CAR AFTER THE CARS 100000 WARRANTY, AND THEN KIA CLAIMS IT IS PAST THE WARRANTY THEY HAVE AND THERE IS NOTHING THEY CAN DO. THIS CAUSES THE GAS TO ALWAYS READ INCORRECTLY EVEN WITH A FULL TANK THE CAR READS "E" I HAVE TO KEEP PUTTING GAS IN THE CAR IN FEAR OF RUNNING OUT OF GAS. *TR
Feb 21, 2013
TL* THE CONTACT OWNS A 2004 KIA SORENTO. THE CONTACT STATED THAT THE FAN RELAY FUSE HAD TO BE REMOVED IN ORDER TO GET THE FAN TO STOP RUNNING. THE CONTACT HAD TAKEN THE VEHICLE TO SEVERAL MECHANICS FOR SERVICE OF ELECTRICAL PROBLEMS HOWEVER, THE MECHANICS WERE NEVER ABLE TO DIAGNOSE THE EXACT CAUSE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN, BUT THE CURRENT MILEAGE WAS 138,000.
Feb 06, 2013
WHEN SHUTTING OFF THE ENGINE THE COOLING FAN STAYS RUNNING. IF THIS IS NOT NOTICED IT WILL RUN UNTIL THE BATTERY DIES AND THEN THE VEHICLE WILL NEED JUMPED. AS I WAS RESEARCHING ON THE INTERNET IT LOOKS LIKE THERE ARE ISSUES WITH RELAYS IN KIA'S FROM 2003 TO 2006. THIS PROBLEM HAPPENS AT LEAST ONCE A MONTH SOMETIMES MORE. THIS TIME THE BATTERY HAD TO BE DISCONNECTED TO GET THE FAN TO SHUT OFF.. THIS IS A SAFETY ISSUE THAT NEEDS TO BE RESEARCHED FARTHER IN REGARDS TO HOW OFTEN THIS HAPPENS. I HAVE NOT TAKEN MY KIA TO A MECHANIC YET DUE TO THE FACT IT IS VERY COSTLY TO TRACK AN ELECTRICAL PROBLEM. THIS PROBLEM DOES NOT HAPPEN ALL THE TIME BUT IF YOU ARE UNAWARE OF THIS PROBLEM YOU MAY GO TO START YOUR CAR AND IT DOES NOT RUN. THERE ARE A HIGH AND LOW FAN ON THIS KIA. BOTH OF THE FANS ARE RUNNING BUT THE HIGH FAN IS ALMOST SILENT. IF THIS PROBLEM HAS BEEN GOING ON FOR AT LEAST FOUR YEARS THERE SHOULD BE SOME WAY TO HOLD THE MANUFACTURER RESPONSIBLE. THANK YOU FOR YOUR TIME.. *TR
Nov 26, 2012
+ 2 more complaints for this component
STEERING
6 complaints
WHILE DRIVING MY VEHICLE AT 65MPG ON THE HIGHWAY WITH MY BABY IN THE CAR, THE STEERING JERKED TO THE LEFT. I ALMOST CRASHED INTO A DESIEL TRUCK !! I THEN CORRECT IT AND PULLED OVER. I DROPPED MY SON OFF AT MY MOM'S HOME AND WENT TO THE GARAGE TO HAVE IT LOOKED AT. ON THE WAY, IT LOST ALL POWER STEERING AND I COULD NOT TURN CORRECTLY. SOMEONE HIT THE BACK OF MY CAR AND SHOVED IT INTO ANOTHER VEHICLE IN THE FRONT. SO NOW MY BACK AND FRON IN LOOKS LIKE CRAP AND I HAVE NO POWER STEERING.. BUT MY SON AND I ARE STILL ALIVE.. WHEN RESEARCHING THIS ISSUE, I FOUND OUT IT WAS NOT MY FAULT OR MY CAR.. THIS IS A FAULTY MANUFACTURE SAFTY ISSUE THAT HAS NOT EVEN BEEN RESEARCHED YET !! THERE HAVE BEEN SO MANY CUSTOMER COMPLAINTS ABOUT THE DANGER OF THIS VEHICLE AND THIS ISSUE I CAN NOT BELIEVE IT'S STILL ON THE ROAD. HTTPS://WWW.CARCOMPLAINTS.COM/KIA/SORENTO/2004/STEERING/STEERING.SHTML AND TO FIND OUT THE STATE WAS AWARE OF IT AND JUST NEVER EVEN LOOKED INTO PROTECTING US. THIS IS A DANGER AND NEEDS TO BE RECALLED ASAP BEFORE SOMEONE LOOSES THEIR LIFE AND THE LIFE OF THEIR CHILD LIKE I ALMOST DID !!!!
May 07, 2019
LOSS OF POWER ASSISTED STEERING DUE TO LOSS OF FLUID FROM CORRODED STEEL LINES BETWEEN STEERING RACK AND STEERING DIRECTIONAL CONTROL UNIT. THIS IS THE THIRD INCIDENT OF CORRODED STEEL LINES ON THIS VEHICLE. FIRST WAS THE BRAKE LINES THEN THE FUEL LINES. PREVIOUS ISSUES WERE ALSO REPORTED ON THIS WEBSITE. *TR
Dec 07, 2013
DRIVING DOWN ROAD AND HEARD NOISE AND FELT LIKE IT WAS LOOSING POWER. PULLED OVER TO PARK THE CAR. LOST POWER STEERING AND WENT UP A SHOPPING STORE CURB. LUCKY THAT NO ONE WAS WALKING OR STANDING THERE. (PULLEY, BROKEN BOLT FROM CRANK AND DIAL PIN FROM CRANK). *TR
Jun 07, 2013
TL* THE CONTACT OWNS A 2004 KIA SORENTO EX. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH, THERE WAS AN UNEXPECTED LOSS OF POWER STEERING. THE CONTACT MANEUVERED THE VEHICLE TO A PARKING LOT WITH DIFFICULT IN TURNING THE STEERING WHEEL. THE VEHICLE WAS THEN TOWED TO AN INDEPENDENT MECHANIC WHO INFORMED THE CRANK SHAFT BOLT FRACTURED. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED.THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 71,000.
Nov 15, 2012
TL* THE CONTACT OWNS A 2004 KIA SORENTO. THE CONTACT STATED WHILE DRIVING 60 MPH THE POWER STEERING FAILED. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER STATED HE USED THE WRONG STEERING FLUID IN THE VEHICLE, WHICH CAUSED THE FAILURE. THE CONTACT EMAILED THE MANUFACTURER AND WAS AWAITING A RESPONSE. THE FAILURE MILEAGE WAS 56,000 AND THE CURRENT MILEAGE WAS 60,000.
Jun 22, 2012
+ 1 more complaint for this component
STEERING,ENGINE
6 complaints
TRAVELING A 45MPH AND CRANKSHAFT PULLEY BROKE OFF INSIDE CRANKSHAFT SPROCKET. 3RD INSTANCE OF SAME PROBLEM. *TR
Aug 15, 2013
TRAVELING AT 40MPH CRANKSHAFT BOLT BROKE OFF INSIDE CRANKSHAFT SPROCKET CAUSING HARMONIC BALANCER AND BELT TO FALL OFF. ALSO HAD TO REPLACE A/C COMP, WATER PUMP AND TIMING BELT DUE TO DAMAGE. 1ST INSTANCE. *TR
Aug 15, 2013
TRAVELING AT 40MPH CRANKSHAFT BOLT BROKE OFF INSIDE CRANKSHAFT SPROCKET CAUSING HARM BALANCER AND BELT TO FALL OFF. 2ND INSTANCE. *TR
Aug 15, 2013
I WAS DRIVING THE CAR WHEN I SUDDENLY STARTED HEARING RATTLING NOISES FROM THE ENGINE. THE POWER STEERING STOPPED WORKING AND THE STEERING WHEEL WOULD NOT TURN. THANKFULLY, I WAS ON A SIDE STREET WITH NO OTHER TRAFFIC. IF I HAD BEEN IN TRAFFIC OR TRAVELING AT A HIGHER SPEED, THIS WOULD SURELY HAVE CAUSED A CRASH. MY MECHANIC SAYS THAT THE CRANKSHAFT BOLT IS SHEARED OFF AND MUST BE DRILLED OUT TO BE REPLACED. KIA WON'T COVER THIS EXPENSIVE REPAIR, SAYS IT IS NOT COVERED BY THEIR WARRANTY. AFTER RESEARCHING THIS ISSUE, I SEE THAT KIA IS AWARE OF A DEFECT IN THE BOLT AND HAS ISSUED SERVICE BULLETINS AND DISCONTINUED THE BOLT, ISSUING A NEW PART TO REPLACE IT. THERE ARE ALREADY NUMEROUS COMPLAINTS ON THIS AND OTHER SITES DUE TO THIS ISSUE, SPANNING SEVERAL MODEL YEARS. TO DATE, I HAVE NOT SEEN A RECALL FROM KIA. DANGEROUS DEFECT AND ALARMING LACK OF CONCERN (NOT TO MENTION CUSTOMER SERVICE) FROM KIA. I WOULD NEVER HAVE BOUGHT THIS CAR IF I HAD KNOWN THE GAMBLE I WAS TAKING WITH MY FAMILY'S SAFETY. I HOPE OTHERS WILL NOT MAKE THE SAME MISTAKE. *TR
Feb 15, 2013
THE CRANKSHAFT PULLEY BOLT BROKE AND MESSED UP THE STEERING, I WAS UNABLE TO STEER THE CAR. THIS HAS HAPPENED TWICE NOW AND CONTINUES TO BE A PROBLEM AS I'M READING THE KIA FORUMS. *TR
Jan 16, 2013
+ 1 more complaint for this component
UNKNOWN OR OTHER
5 complaints
MY SORENTO WAS IN PARK RUNNING IN MY DRIVEWAY STARTED SMOKING AND CAUGHT FIRE AND BURNED UP IN A MATTER OF MINUTES. I'M AWARE OF RECALLS WITH KIA VEHICLES CATCHING FIRE. I WOULD LIKE THIS TO BE ADDRESSED AND INVESTIGATED AS I FEEL IT WAS DUE TO A MALFUNCTION. 911 WAS CALLED AND THE FIRE DEPARTMENT CAME TO DISTINGUISH THE CAR IT IS A TOTAL LOSS.
Mar 09, 2019
VEHICLE CAUGHT FIRE WHILE STATIONARY. FIRE STARTED IN FRONT COMPARTMENT NEAR FUSES. TOTAL LOSS
Sep 12, 2018
THE VEHICLE WAS STATIONARY. WE ARE A FAMILY OF FOUR. ONE OF US OPEN ONE OF THE REAR DOORS AND THE HANDLE CAME OUT COMPLETELY. I DON'T KNOW IF IT CAN BE REPAIR OR NOT. I COVER THE HOLE WITH TAPE TO PROTECT THE INNER PARTS OF THE DOOR FROM THE WATER. THE SAME THING HAPPENS WITH THE HANDLE OF THE OTHER REAR DOOR. BUT IN THIS CASE IT DOES NOT COME OUT COMPLETELY AND I USE TAPE TO MAINTAIN IT IN POSITION. IF SOMETHING HAPPENS AND THE PERSONS IN THE BACK SITS ARE UNABLE TO OPEN THE REAR DOORS FROM THE INSIDE ONE OF THE PERSONS IN THE FRONT SITS HAVE TO GET OUT THE CAR AND OPEN THE DOOR THAT STILL HAVE THE TAPED HANDLE. I DON'T KNOW IF THIS SITUATION IS GOING TO AFFECT THE MECHANISM OF THE INTERIOR HANDLES OF THE REAR DOORS. I DON'T KNOW IF THE TAPED HANDLE IS GOING TO BRAKE OR WHEN IS GOING TO BRAKE. I READ IN THE INTERNET THAT THIS A PROBLEM OF THE SORENTOS OF SEVERAL YEARS. SOME OF THE PERSONS IN THE INTERNET ASK WHY KIA IS NOT MAKING A RECALL. I HAVE A DAUGHTER OF 16 YEARS AND A SON OF ALMOST 15 YEARS. MY SON DOES NOT HAVE MANY LIMITATIONS, BUT HE HAS A SYNDROME. I AM INCLUDING PHOTOS OF THE DOORS.
Dec 19, 2016
TOOK CAR TO MY MECHANIC FOR SMALL LEAK IN RADIATOR AND ASKED THAT HE CHECK THE BRAKES BECAUSE I HEARD A LOUD NOISE FROM THE REAR OF THE VEHICLE. UPON CHECKING THE BRAKES (WHICH WERE O.K.) HE FOUND THE REAR FRAME TO BE COMPLETELY RUSTED THROUGH. HE NOTED THE VEHICLE WAS UNSAFE AND DANGEROUS TO DRIVE AS THERE WAS A RISK OF REAR DRIVETRAIN DETACHING FROM VEHICLE. THIS SEEMS TO BE A PROBLEM KNOWN TO KIA -- AS THERE WAS A RECALL IN EUROPE FOR THIS PROBLEM-- BUT NOT THE US. I ALREADY CONTACTED KIA AND THE ONLY RESPONSE I RECEIVED WAS TO TAKE IT TO A KIA DEALER FOR DIAGNOSIS. WE WOULD HAVE TO PAY FOR A DIAGNOSTIC TEST WHEN WE ALREADY KNOW WHAT THE PROBLEM IS. KIA DOES NOT GIVE ANY GUARANTEE THAT THEY WOULD REIMBURSE US FOR THE TEST OR ANYTHING ELSE. PLEASE LET US KNOW WHAT WE CAN DO. HOW CAN WE GET KIA TO ACT RESPONSIBLY? THERE ARE MANY OTHER COMPLAINTS ABOUT THIS SAME PROBLEM
May 30, 2016
CRANKSHAFT PULLEY BOLT_WHILE DECELERATING TO MAKE A TURN, I LOST MY POWER STEERING AND POWER BRAKES. THE BRAKE AND BATTERY INDICATOR LIGHTS CAME ON. THANKFULLY, I WAS NOT INVOLVED IN A POTENTIALLY SERIOUS ACCIDENT. I MANAGED TO MAKE IT HOME THE LAST TWO MILES USING BATTERY TO SUPPLY IGNITION. THE 2 OF THE 3 BELTS HAD DISLODGED AND THE CRANKSHAFT PULLEY WAS LOSE TO THE POINT THAT IT NEARLY DETACHED FROM THE CRANKSHAFT END. I AM GREATLY DISTURBED THAT, AFTER SOME RESEARCH, DISCOVERED THAT THIS EXACT FAILURE HAS BEEN REGULARLY DOCUMENTED. I PURCHASED MY UNIT USED SO I AM UNAWARE IF A PREVIOUS REPAIR HAD BEEN MADE BY KIA. I HAVE NOT RECEIVED ANY NOTIFICATION OF SUCH. THIS IS A VERY SERIOUS ISSUE. I AM THANKFUL THAT I WAS IN A RURAL AREA WHEN THIS FAILURE OCCURRED. BASED UPON SOME RESEARCH FINDINGS, I HOPE THAT I DO NOT EXPERIENCE BALKING WHILE ATTEMPTING TO HAVE THIS ISSUE REMEDIED, AS OTHERS HAVE. I HAVE REVIEWED SOME DISCUSSION REGARDING A SERVICE BULLETIN #018 (NHTSA ITEM NUMBER : 10009688 DATE OF BULLETIN : JUL 01, 2004 CRANKSHAFT PULLEY BOLT) ISSUED BY KIA CONCERNING THIS FAILURE. I WILL BE ARRANGING FOR THE UNIT TO BE DELIVERED TO MY NEAREST KIA DEALER (45 MILES AWAY IN QUINCY, IL).
Mar 06, 2011
SUSPENSION,STRUCTURE
5 complaints
2004 KIA SORENTO EX WITH EXTENSIVE RUST DAMAGE TO REAR CROSS-MEMBERS #2 AND #3. DISCOVERED DURING TIRE ROTATION IN NOV 2018, BUT IS OBVIOUS THE DAMAGE HAS EXISTED FOR A SUBSTANTIAL AMOUNT OF TIME. CROSS-MEMBER #2 IS JUST IN FRONT AND ABOVE THE REAR AXLE AND HAS THE MOUNTING BRACKETS FOR THE AXLE STRUTS, WHICH KEEP THE AXLE IN PLACE, IT ALSO HAS A MOUNTING BRACKET FOR THE FUEL TANK, AS WELL AS A PASS THROUGH BRACKET FOR THE REAR BRAKE LINES, AND A MUFFLER HANGER. THE CAR IS NOT SAFE TO BE DRIVEN DUE TO THE IMMINENT DANGER OF A FULL FAILURE. CROSS-MEMBER #2 IS ABOUT 70% RUSTED THROUGH ON THE FUEL TANK SIDE AND PERFORATED IN SEVERAL OTHER PLACES AS WELL. CROSSMEMBER #3 WHICH IS BEHIND THE REAR AXLE CONTAINS NO MOUNTS, BUT A TORSION BAR DOES CONNECT WHERE THE CROSS-MEMBER PASSES THROUGH THE LEFT FRAME RAIL. STRUT MOUNT CONNECTORS ON AXLE ARE ALSO SEVERELY RUSTED. BACKING PLATE FOR REAR DISC BRAKES ON BOTH SIDES IS RUSTED SO SEVERELY THEY CRUMBLE LIKE AN EGGSHELL. CONTACTED KIA AND THEY SAID THEY WILL NOT COVER REPAIR OF THE DEFECT, CASE #12944853 OPENED. IT ONLY TAKES A QUICK SEARCH ONLINE TO FIND THERE ARE MANY CASES OF THIS WITH PARTICULARLY 2004 MODELS.
Nov 23, 2018
TL* THE CONTACT OWNS A 2004 KIA SORENTO. WHILE DRIVING APPROXIMATELY 50 MPH, THE REAR OF THE VEHICLE SHOOK VIOLENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO NOTICED THAT THE CROSSMEMBER BARS WERE CORRODED THROUGH AND WERE NOT ABLE TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 150,000. THE VIN WAS NOT AVAILABLE.
Aug 30, 2017
PURCHASED USED, WAS DRIVING TO GRANDSON'S BALL GAME, WHEN CAR STARTED MAKING FUNNY NOISE AND ACTED AS THE THE REAR END WAS GOING TO FALL OUT, WE PULLED OVER IN GROCERY STORE PARKING LOT, GOT OUT AND LOOKED, COULD NOT SEE ANYTHING, HAD DAUGHTER FOLLOW US HOME, JUST IN CASE, TOOK IT TO FRIEND WHO NOTICED THE REAR BRACKET ARMS ARE COMPLETELY RUSTED OUT , LOOKS LIKE IT IS WHAT HOLDS THE REAR END IN PLACE. I'M NOT SURE WHAT TO DO, I PAID OVER $5000 USED AND I CAN'T JUST PARK IT, I THINK KIA SHOULD BE RESPONSIBLE FOR THIS MISHAP, IT IS NOT LIKE IT CAN JUST BE FIXED, IT NEEDS REPLACED, SO I'M THINKING IT WOULD BE A MAJOR JOB, I'VE READ MANY MANY OTHER FORUMS AFTER FINDING THIS OUT ABOUT MINE AND RESEARCHING, I"M SURE THIS COULD POTENTIALLY BE A SERIOUS OR EVEN LIFE THREATENING PROBLEM, I'M NOT SURE I WOULD WANT TO SELL IT TO SOMEONE ELSE, IF IT IS DANGEROUS, I WOULD REALLY LIKE TO KNOW THE SERIOUSNESS OF THIS PROBLEM, IS THIS A MINOR OR MAJOR PROBLEM, IS THERE MORE HOLDING THAT REAR END IN PLACE THEN JUST THOSE RUSTED OUT ARMS OR BRACKETS? WOULD YOU WANT YOUR DAUGHTER DRIVING THIS?, I DON'T KNOW IF THE PREVIOUS OWNER WAS AWARE OF NOT, IF SO WE WERE NOT NOTIFIED, I WOULD HATE TO THINK I COULD BE DRIVING DOWN THE ROAD WITH MYSELF AND GRANDBABIES AND SOMETHING HORRIBLE HAPPEN. PLEASE HELP, I"M REALLY CONCERNED ABOUT THIS, ESPECIALLY AFTER ALL THE TROUBLE WITH THE CRANKSHAFT BOLT I" READING ABOUT. I'M SCARED TO DEATH TO DRIVE THIS THING, IF IT HAD NEVER WENT UP ON A RACK WE WOULD BE NONE THE WISER AND WOULD STILL BE DRIVING DAILY JUST AS IF WE DID NOT KNOW, BUT NOW THAT I KNOW, I DON'T KNOW WHAT TO DO.. THIS IS A REAL SAFETY ISSUE, THERE IS TO MUCH NONSENSE CAR DEALERS GET AWAY WITH ANYWAY FOR US CONSUMERS TO WORRY ABOUT OUR LIVES OR SOMEONE ELSE'S WHILE DRIVING. WILL THE REAR END FALL OUT? IS IT SAFE TO DRIVE? YOU TELL ME? WOULD YOU DRIVE IT?
Aug 08, 2016
TL* THE CONTACT OWNS A 2004 KIA SORENTO. THE CONTACT STATED THAT THE STABILITY BAR/TORQUE BAR THAT SUPPORTS THE REAR SUSPENSION FOR THE TIRE WAS NOT STRUCTURALLY SOUND AND HAD EXTENSIVE RUST AND CORROSION ON THE PIPING. THE PARTS NEEDED TO BE REPLACED. THE MECHANIC INDICATED THAT THE MANUFACTURER NEEDED TO PROVIDE A PERMANENT REPAIR OR SOLUTION TO REPAIR THE VEHICLE, AND RECOMMENDED THAT THE VEHICLE BE INSPECTED AND DIAGNOSED BY A DEALER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000. UPDATED 10/13/16*LJ *TR
Mar 30, 2016
WAS DRIVING VEHICLE WHEN FRAME BROKE AND ALMOST CRASHED IT FOUND OUT FROM A BODY SHOP THAT THE FRAME HAD CORRODED AND BROKE AND WE OWE MONEY ON THIS PIECE OF JUNK AND THE KIA CORPORATION HAS NEVER HEARD OF THIS HAPPENING. *TR
Jan 08, 2014
EXTERIOR LIGHTING
5 complaints
THE INTERIOR LIGHTS DO NOT STAY ON THE WHEEL I HAVE TO PLAY WITH IT TO GET THEM TO COME ON AND THEY GO OFF ALL THE TIME WHICH IS VERY DANGEROUS DRIVING AT NIGHT. AND MY LOW BEAMS DO NOT WORK AT ALL I HAVE TO DRIVE WITH HIGH BEAMS ON.
Jul 27, 2018
I WAS DRIVING TO A FAMILY MEMBERS HOUSE AT NIGHT. WHEN WE GOT THERE HE TELLS ME I HAVE NO LIGHTS IN THE BACK. THE NEXT DAY I WENT TO THE AUTO STORE AND BOUGHT NEW LIGHTS TO PUT IN. THAT DID NOT WORKING SO I WENT BACK. HE HOOKED IT UP TO THE COMPUTER AND FOUND OUT IT WAS A BRAKE LIGHT SWITCH. I GOT THAT REPLACED. I START LOOKING UP ON LINE FOR ANOTHER ISSUE I AM HAVING AND FOUND OUT THAT ALOT OF OTHER KIAS HAVE HAD THE SAME ISSUE.
Nov 27, 2015
2004 KIA SORENTO. THE REAR TAIL LIGHTS AND FRONT FOG LIGHTS BURN OUT FREQUENTLY. THIS LEAVES ME UNKNOWINGLY DRIVING AT NIGHT WITHOUT PROPER LIGHTING. I USUALLY FIND OUT WHEN OTHER DRIVERS TELL ME MY LIGHTS ARE OUT. THERE IS EITHER AN ELECTRICAL OR FUZEBOX PROBLEM WITH THE KIA SORENTO FROM 2003-06. SO FAR, KIA HAS REFUSED TO ACKNOWLEDGE THE PROBLEM. I FOUND MANY SIMILAR COMPLAINTS ONLINE SUCH AS HTTP://TOWNHALL-TALK.EDMUNDS.COM/DIRECT/VIEW/.F14D197/. *TR
Jun 05, 2011
HEADLIGHTS, TAILLIGHTS BLOW OFTEN AND FAKE CHROME PLATING ON DOOR INSIDE HANDLE PEELING AWAY AND CUTTING FINGERS. *TR
Nov 15, 2008
TL*THE CONTACT OWNS A 2004 KIA SORENTO. THE FAILURE MILEAGE WAS 20000 AND THE CURRENT MILEAGE WAS 41380. THE TAIL LIGHTS HAD BEEN CHANGED FIVE TIMES AND KEPT BURNING OUT. THE CONTACT STATED THE TAIL LIGHTS WERE A SAFETY ISSUE BECAUSE SOMEONE COULD RUN INTO THE BACK OF THE VEHICLE.*AK
May 02, 2007
TIRES
4 complaints
TL* THE CONTACT OWNS A 2004 KIA SORENTO EX. THE VEHICLE HAS KUMHO RADIAL 798 TIRES, LINE SIZE P245/70/R16, MANUFACTURED MARCH 2006. THE CONTACT STATED THAT THE TIRES WERE EXHIBITING ABNORMAL FRACTURES. THE TIRE DISTRIBUTOR WAS CONTACTED AND ADVISED THAT THE FAILURE WAS CAUSED BY THE HOT CLIMATE. THE TIRES WERE NEITHER REPAIRED NOR REPLACED. THE FAILURE MILEAGE OF THE TIRES WAS 16,000. THE VEHICLE FAILURE MILEAGE WAS 52,501 AND THE CURRENT MILEAGE WAS 52,793. UPDATED 05/03/2011*LJ UPDATED 1/5/12 *CN
Mar 03, 2011
FRONT PASSENGER TIRE TREAD CAME OFF WHILE DRIVING DOWNHILL ON A MOUNTAIN ROAD AND CAUSE PASSENGER AIRBAG TO DEPLOY, WE WERE LUCKY CAR DID NOT ROLL OVER AND WE ALL WERE KILLED. BRIDGESTONE IS THE TIRE MANUFACTURER (DUELER 684, P245/70R16) AND WHEN I DO A WEB SEARCH ALL KINDS OF INFORMATION COMES UP WITH RECALLS BUT COULD NOT FIND MY TIRE TYPE BUT FOUND ALL KINDS OF BLOGS WITH PEOPLE COMPLAINING ABOUT MY TYPE OF TIRE AND THE TREAD COMING OFF. *TR
Aug 24, 2009
DRY ROT. *TR
Sep 06, 2007
DT*: THE CONTACT STATED THE VEHICLE HAD AN UNCONTROLLED HYDROPLANE INCIDENT ON WET PAVEMENT WHICH RESULTED IN THE VEHICLE CROSSING THREE TRAFFIC LANES AT 45-50 MPH. THIS OCCURRED WHILE ENTERING THE FREEWAY. THERE WERE NO WARNINGS INDICATING A PROBLEM. *AK UPDATED 01/25/06.
Jan 05, 2006
STRUCTURE,SERVICE BRAKES
3 complaints
WHILE MY DAUGHTER WAS DRIVING ON THE HIGHWAY, THE BRAKES FAILED. THE MECHANIC SHOWED ME THE BRAKE LINES TOWARD THE REAR SUSPENSION RUSTED THROUGH. ALSO THE SUPPORT FOR THE REAREND RUSTED THROUGH MAKING THE VEHICLE DANGEROUS TO DRIVE. THE BRAKE LINES FROM FRONT TO BACK WERE CHANGED AND I AM LOOKING TO HAVE THE SUPPORT BRACKETS CHANGED.
Jan 21, 2020
I WENT TO GET MY OIL CHANGED ON/AROUND 9/5 AND THEY WOULDN'T CHANGE IT DUE TO SEVERE RUST DAMAGE THAT HAD RUSTED THROUGH THE OIL PAN, BRAKE LINE, AT LEAST ONE CRACK IN THE FRAME FROM RUST, AND THE TIRES ARE BARELY HELD ON TO THE CAR DUE TO RUST DAMAGE. NOW MY BRAKES DON'T WORK BUT I STILL HAVE TO DRIVE THE CAR. I WENT TO 2 OTHER SHOPS AND NO ONE WILL WORK ON MY CAR DUE TO IT FALLING APART FROM RUST. I PURCHASE MY CAR AT ABC MOTOR CREDIT AUGUST OF 2013 AND RE-LOCATED TO FLORIDA BEFORE WINTER HIT. I CALLED THEM AND THEY REFERRED ME THEIR WARRANTY COMPANY, LISA WARRANTY GROUP. OF COURSE, RUST DAMAGE AND FRAME WORK IS NOT COVERED. ABC MOTOR CREDIT SOLD ME A CAR THAT SHOULD HAVE BEEN TOTALED, NOT RE-SOLD TO A CONSUMER FOR $12,000!! I HAVE TRIED 5 DIFFERENT DEALERSHIPS TO HELP GET INTO A NEWER, SAFER VEHICLE, BUT NO ONE WILL FINANCE ME DUE TO THE NEGATIVE EQUITY ON THIS LOAN. IS THERE ANYTHING I CAN DO? I SHOULD NOT BE STUCK PAYING $367 A MONTH FOR THE NEXT 2 YEARS AFTER ALREADY INVESTING OVER $4,000 INTO A USELESS VEHICLE. I HAVE TO CONCLUDE THAT ABC MOTOR CREDIT SOLD ME THIS CAR FULLY KNOWING THE EXTENT OF THE RUST DAMAGE BEFORE PUTTING IT ON THEIR LOT. I HOPE THERE IS SOME LAW PROTECTING CONSUMERS FROM THIS SORT OF BUSINESS. PLEASE LET ME KNOW WHAT I CAN DO! *TR
Oct 09, 2014
TL* THE CONTACT OWNS A 2004 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, THE BRAKES MALFUNCTIONED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE COULD NOT BE REPAIRED DUE TO RUSTING OF THE FRAME, WHICH DAMAGED THE BRAKE LINES. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 136,000.
Dec 06, 2013
VEHICLE SPEED CONTROL
3 complaints
IT DRIVES FINE THEN ALL OF A SUDDEN FOOT SAME POSITION ON GAS PETAL IT ACCELERATES.
Aug 25, 2018
TL* - THE CONTACT OWNS A 2004 KIA SORENTO, WHEN THE CONTACT LIFTS THE FOOT OFF THE GAS PEDAL THE THROTTLE CABLE STICKS. THERE WAS A COLLISION WHILE DRIVING 25 MPH, THE VEHICLE WAS DAMAGED ON THE PASSENGER SIDE, AND THE PASSENGER WAS INJURED RESULTING IN A 2 DAY HOSPITAL STAY. THIS FAILURE OCCURRED ON TWO OCCASIONS. THE CONTACT HAS REFERENCED RECALL#05V329000 AS THE EXACT FAILURE IN HIS VEHICLE. THE RECALL STATED THAT ON CERTAIN MINI VANS, FREEZING CONDITIONS CAN CAUSE WATER ON THE THROTTLE CABLE TO FREEZE DURING NORMAL OPERATION. RESISTANCE TO MOVEMENT OF THE THROTTLE CABLE CAN OCCUR WHEN THE DRIVER LIFTS THEIR FOOT OFF OF THE GAS PEDAL. A POLICE REPORT WAS FILED. THE FAILURE MILEAGE WAS 19585 AND THE CURRENT MILEAGE IS 19591.*AK UPDATED 2/21/2007 - *NM
Jan 23, 2007
SPEEDOMETER READS FAST. ACCORDING TO KIA AT 60 MPH IT IS IN TOLARENCE PLUS OR MINUS 7-8 MPH.*AK
Jun 24, 2004
FUEL/PROPULSION SYSTEM
3 complaints
WHILE TRYING TO REFULE THE GASOLINE WILL SUDDENLY "SPRAY" FROM THE TANK. VEHICLE STATIONARY.
Jun 21, 2017
TL* THE CONTACT OWNS A 2004 KIA SORENTO. THE CONTACT STATED THAT WHILE REFUELING THE VEHICLE, THE FUEL WOULD SPEW OUT OF THE TANK. THE CONTACT ALSO STATED THAT THE VEHICLE HAD BEEN REPAIRED UNDER A MANUFACTURER RECALL FOR THE SAME FAILURE IN 2012. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 135,000. THE VIN WAS NOT AVAILABLE.
Feb 11, 2016
WHEN REFUELING THE TANK WILL SUDDENLY "SPRAY"GASOLINE FORCEFULLY FROM THE NECK OF THE GAS TANK FOR SEVERAL SECONDS. TOOK IT IN ON THE VOLUNTARY RECALL AND HAD THE AIR FILTER REPLACED. CAR WORKED FINE FOR ABOUT 2 WEEKS BUT IS NOW EXPERIENCING THE SAME PROBLEM AGAIN. PUMPED LESS THAN $25.00 IN THE TANK TWO NIGHTS AGO AND WAS SPRAYED WITH GASOLINE! *TR
Apr 04, 2013
SUSPENSION,POWER TRAIN
3 complaints
RUSTED BRACKETS POSING A DANGEROUS SAFETY RISK, 2004 KIA SORENTO WITH 162,000 MILES. THE ENTIRE BRACKET HOLDING THE DIFFERENTIAL RUSTED THROUGH. THE FRAME REAR CROSS MEMBER ALSO RUSTED THROUGH CAUSING THE CONTROL ARMS IS DETACHED FROM THE REAR END ALSO CREATING A SAFETY HAZARD. THERE IS A DESIGN FLAW THAT ALLOWS WATER TO STAY INSIDE THE HOLLOW CROSS MEMBER THAT CAUSED THE CORROSION. DRAIN OR WEEP HOLES IN THE CROSS MEMBER AND AN ANTI-CORROSION COATING WOULD HAVE PREVENTED THIS. WHEN THE BRACKET(S) BREAKS THE REAR AXLE IS NO LONGER HELD IN PLACE THERE ARE REPORTS ON NHTSA WHERE THESE BRACKETS HAVE ROTTED AWAY AND FAILED CAUSING LOSS OF CONTROL OF THE VEHICLE. THIS IS A KNOWN DESIGN FLAW THAT HAS BEEN APPEARING ON THE OLDER CARS WHERE THE ENTIRE FRAME AND REAR END WOULD HAVE TO BE REPLACED. THERE WILL EVENTUALLY BE MORE OF THESE FAILURES AND THERE IS A POTENTIAL FOR FATAL ACCIDENTS FROM LOSS OF VEHICLE CONTROL. I AM AWARE THAT IN EUROPE KIA HAS BEEN REPAIRING SORENTOS.
Jul 29, 2016
RUSTED BRACKETS RECALLED IN EUROPE, REFUSED BY KIA TO REPLACE EVEN THO THEY WERE RUSTED UNDER WARRANTY, POSE A DANGEROUS SAFETY RISK TO UNSUSPECTING OWNERS. THE ENTIRE BRACKET HOLDING THE DIFFERENTIAL RUSTED THROUGH CREATING A SAFETY HAZARD. PRESENTED WITH A SMALL SQUEAK IN REAR. I ASKED KIA TO SEND PEOPLE LETTERS WARNING AND THEY WOULD NOT ADDRESS THE REQUEST. HOW KIA IS GETTING AWAY WITH SEVERE RUST, CAUSING SAFETY HAZARDS IN ALL VEHICLES, IS BEYOND ME. I KNOW THEY ARE LESS EXPENSIVE, IS IT WORTH IT? CAN SOMEONE PLEASE ADDRESS THE ISSUE AND AT LEAST LET THE PUBLIC KNOW IT IS HAPPENING BEFORE SOMEONE GETS SEVERELY INJURED OR GOD FORBID DIES. THERE ARE THOUSANDS STILL ON THE ROAD. I PAID FOR THEIR DIAGNOSTIC WORTHLESSNESS TO MAKE SURE IT WAS DOCUMENTED.
Jul 17, 2016
TWO BRACKETS (ONE LEFT, ONE RIGHT) THAT HOLD THE REAR UPPER CONTROL ARMS TO THE REAR AXLE HOUSING HAVE COMPLETELY SNAPPED OFF. THIS LEAVES A VERY DANGEROUS CONDITION WHICH WILL CAUSE THE REAR AXLE OF THE CAR TO ROTATE AND FALL OUT OF THE CAR. IF THIS HAPPENS AT SPEED, SERIOUS INJURY AND/OR DEATH IS LIKELY. THERE ARE MANY MANY POSTS ABOUT THIS SAME PROBLEM ONLINE AND KIA REFUSES TO ADDRESS THE PROBLEM STATING THAT IT'S NOT A FLAW OR DEFECT. IT IS IF IT HAPPENS TO ALMOST EVERY VEHICLE OF THIS YEAR AND MODEL. KIA DOES NOT OFFER A REPLACEMENT BRACKET THAT CAN BE WELDED ON AND THEY SUGGEST THAT THE ENTIRE REAR AXLE HOUSING ASSEMBLY IS REPLACED AT A COST OF SEVERAL THOUSAND DOLLARS PER VEHICLE. KIA MOTORS REFUSES TO ACKNOWLEDGE THE PROBLEM OR ASSIST AFFECTED CUSTOMERS IN RESOLVING IT. *TR
Aug 18, 2012
STEERING,ELECTRICAL SYSTEM,ENGINE
2 complaints
I BOUGHT MY 04 SORENTO FROM MY AUNT WHO WAS THE ONLY OWNER. IT HAD A POWER STEERING ISSUE AT THAT TIME WHICH TOOK SEVERAL ATTENPTS TO FIX. ABOUT A MONTH LATER WE WE VISITING FAMILY AND HAD TO TURN AROUND. UPON STOPPING WE NOTICED SMOKE FROM THE ENGINE COMPARTMENT SO I GRABBED MY 4 Y/O DAUGHTER OUT OF THE CAR AND BY BOYFRIEND OPENED THE HOOD TO FIND A SMALL FIRE ON OPPOSITE SIDE FRO WHERE BATTERY IS. ONCE FIRE WAS PUT OUT WE DROVE .5 MILES ON A CITY RD TO FAMILY. THE POWER STEERING WAS GONE AT THAT TIME AS WELL. 10/13/19 - THE DIRECTIONAL WORKED ALL DAY AND COME NIGHT TIME WHEN I CAME OUT FROM THE STORE AND STARTED VEHICLE THEY DID NOT WORK. THE NEXT DAY THEY WORKED FINEHOWEVER, ON 10/14/19 - I STARTED THE CAR IN AM AND THERE WAS A SQUEAKY BELT. I HIT THE GAS PEDAL QUICKLY AND NOISE WENT AWAY. THEN WHILE DRIVING, THE BATTERY AND BRAKE INDICATOR LIGHTS CAME ON THE DASH AND STAYED ON SO I PULLED OVER AND SHUT CAR OFF. IWAS DRIVING MY DAUGHTER TO THE PARK A MILE AWAY FROM HOME WHEN THE BATTERY AND BRAKE INDICATOR LIGHTS CAME ON AGAIN. I TURNED CAR OFF FOR A FEW MINUTES AND WHEN I RESTARTED IT THE LIGHTS WERE OFF. I WENT TO TURN AROUND TO GO HOME AND THE STEERING COMPLETELY FAILED SO IT WAS EXTREMELY DIFFICULT AND DANGEROUS. I HAVE NOT DRIVEN IT OR STARTED IT SINCE. MY MECHANIC CAMT TO MY HOME 2 DAYS IN A ROW AND WAS CONVINCED IT WAS CRANKSHAFT BOLT THAT SNAPPED. HE GOT IT INTO HIS SHOP THE FOLLOWING WEEK ON FRIDAY 10/26/19 AND CALLED A SHORT WHILE LATER INFORMING ME THAT IT WAS IN FACT THE CRANKSHAFT BOLT THAT SNAPPED DEEP IN THE SHAFT AND THE CRANKSHAFT WOULD NEED TO BE REPLACED FOR A COST OF AROUND $3000. I CALLED A FEW OTHER PLACES AND THEY SAID THE ENGINE WOULD NEED REPLACING WHICH WOULD COAT AROUND THE SAME. MY DAUGHTER AND I NOW HAVE NO VEHICLE AND ARE WALKING HER TO SCHOOL WHICH WILL BE DIFFICULT COME WINTER MONTHS.
Oct 26, 2019
WAS DRIVING DOWN THE ROAD AT 55 POWER STEERING WENT CAR LOST POWER LIGHTS WENT CRAZY CAR SHUT DOWN. I ALMOST WRECKED HARMONIC BALANCER FELL INTO PIECES ALL PULLEY BELTS AND PIN HAVE TO BE REPLACED. I JUST GOT THIS CAR I HAVE A PAYMENT ON IT. GOING TO COST 1200 TO FIX. THIS IS ON TOP OF IT SPUTTERING AND SPOTTYING. REPLACE HEAD LIGHTS THE RADIO GLITCHES THE AIR BAG LIGHT IS ON ALL THE TIME AND IF U TURN THE INTERIOR DASH LIGHTS UP IT TURNS THE INTERIOR LIGHTS ON.OVER DRIVE BUTTON DOES NOT WORK AND TRANSMISSION LAGS... I HAVE READ AL THESE COMPLAINTS OVER AND OVER AGAIN WHY ISN'T ANYONE FORCING A RECALL? THESE ARE SERIOUS ISSUES I ALMOST GOT REAR ENDED AND THE ELECTRICAL PROBLEM COULD CAUSE FIRE.... SOMEONE IS GOING TO END UP VERY HURT IF KIA IS NOT FORCED TO FIX THESE. COULD U IMAGINE THIS HAPPENING ON A THRU WAY? *TR
Mar 08, 2015
SUSPENSION,UNKNOWN OR OTHER
2 complaints
WHILE DRIVING APPROXIMATELY 35 MPH, THE REAR OF THE VEHICLE SHOOK VIOLENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO NOTICED THAT THE CROSSMEMBER BARS WERE SEVERELY CORRODED THROUGH AND WERE NOT ABLE TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. MAJOR SAFETY HAZARD. THE ENTIRE BRACKET HOLDING THE DIFFERENTIAL RUSTED THROUGH. THE FRAME REAR CROSS MEMBER ALSO RUSTED THROUGH CAUSING THE CONTROL ARMS IS DETACHED FROM THE REAR END ALSO CREATING A SAFETY HAZARD.
Feb 15, 2018
I BROUGHT THIS VEHICLE FOR INSPECTION AND WAS TOLD IT WILL NOT PASS BECAUSE ONE OF THE CONTROL ARMS IS DETACHED IN THE REAR END. I WAS TOLD NOT TO DRIVE THE VEHICLE AT ALL BECAUSE IT IS NOT SAFE. ADDITIONALLY THERE IS ROT UNDER THE ENTIRE VEHICLE. THE LEFT SIDE FRAME WAS WELDED AND REPAIRED BY THE PREVIOUS OWNER BUT THE RIGHT SIDE IS NOW RUSTED BADLY AND IN NEED OF REPAIR. AXLES ARE LEAKING DUE TO RUST. BRAKES ARE A PROBLEM BUT I HAVEN'T INVESTIGATED FURTHER TO KNOW IF ITS CAUSED BY ROT. I HAVE BEEN ON MULTIPLE FORUMS FOR THIS ISSUE AND IT SEEMS MANY PEOPLE HAVE SAME ISSUES ESPECIALLY THE CONTROL ARM PROBLEM. I CAN NOT RETURN THIS VEHICLE BECAUSE I WAS SCAMMED AND AM NOW STUCK WITH A DANGEROUSLY ROTTED CAR. I AM TOLD ITS NOT WORTH FIXING. THIS CAR LOOKS FINE AND WITHOUT LOOKING UNDERNEATH A PERSON WOULD NOT KNOW A PROBLEM EXISTED PERHAPS UNTIL AN ACCIDENT.
Sep 21, 2015
STEERING,UNKNOWN OR OTHER,ENGINE
2 complaints
I WAS DRIVING DOWN THE ROAD AND ALL OF A SUDDEN MY CARS WOULDN'T TURN THE BATTERY LIGHT CAME ON AND IT WAS ACTING LIKE IT WAS DYING. IT HAPPENS A BOUT 5 MILES FROM HOME AND WHEN I GOT IT THERE I TOLD MY HUSBAND. HE LOOKED AT IT AND TOLD ME MY HARMONIC BALANCER WAS LOOSE AND IT LOOKED TO HAVE SNAPPED THE BOLT. NOW I CANNOT DRIVE MY VEHICLE UNTIL I CAN GET THE BROKEN BOLT OUT AND GET IT FIXED. I LOOKED UP WHAT TO DO AND NOTICED I AM NOT THE ONLY PERSON 28TH THIS PROBLEM.
Sep 12, 2016
IN THIS INSTANCE, THE CAR FAILED TO START. HOWEVER, THERE WERE SEVERAL MORE INCIDENTS CONCERNING THE SAME ISSUES. IN THOSE INSTANCES, THE CAR WOULD SUDDENLY LOSE POWER, STALL OUT AND IF ABLE TO BE RESTARTED, COULD BE DRIVEN WITH A LAG IN THE ENGINE A SHORT DISTANCE BEFORE ALL THE DASH LIGHTS WOULD TURN ON AND THE CAR WOULD LOSE POWER STEERING. IN TWO INSTANCES, THE POWER STEERING WAS SUDDENLY LOST WHEN MAKING A LEFT TURN WITH A BREAK ACROSS ONCOMING TRAFFIC.
May 13, 2015
POWER TRAIN,ELECTRICAL SYSTEM
2 complaints
I WAS ON MY WAY TO WORK ON TUESDAY, MARCH 3, 2015. IT WAS ABOUT 7:30/7:40 A.M. I WAS DRIVING MY 2004 KIA SORENTO EX. I HAD JUST DRIVEN THROUGH ST. PETER, MN ON HWY 169 SOUTH ON MY WAY TO MANKATO AND WAS STARTING TO PICK UP MY SPEED AS THE SPEED LIMIT INCREASES AS YOU LEAVE TOWN. ALL OF A SUDDEN, WITHOUT WARNING, MY VEHICLE JUST SHUT DOWN. THE "DUMMY LIGHTS" ALL LIT UP. I HAD NO POWER STEERING, NO BRAKES, NO ACCELERATOR - NOTHING WAS WORKING. THANK GOODNESS THE VEHICLE, BECAUSE THERE WAS NO POWER, SLOWED TO A STOP WITHIN A SHORT PERIOD OF TIME. I WAS ABLE TO PULL OVER WITHOUT A COLLISION AND NO ONE WAS HURT. I PUT IT IN PARK AND TURNED THE KEY TO THE OFF POSITION. I TRIED TO SEE IF IT WOULD START AGAIN AND ABSOLUTELY NOTHING HAPPENED WHEN I TURNED THE KEY. I CALLED AAA AND THE SORENTO WAS TOWED TO THE NEAREST MECHANIC SHOP. WITHOUT INVESTING TOO MUCH TIME IN IT BECAUSE I DIDN'T WANT A HUGE BILL, THE MECHANIC TOLD ME THAT IT HAS ELECTRICAL POWER - HAS GOOD POWER TO THE STARTER, BUT THE ENGINE DOES NOT ROTATE. THEY COULD NOT EVEN PHYSICALLY ROTATE THE ENGINE. HE TOLD ME THAT REGARDLESS OF WHAT IT WAS, IT WOULD BE VERY EXPENSIVE TO REPAIR IT BECAUSE, AT THIS POINT, THEY HAVE NO IDEA WHAT IS WRONG WITH IT. THAT'S WHEN I GOT ON FACEBOOK AND STARTED ASKING IF ANYONE HAD ANY IDEAS OF WHAT COULD BE WRONG AND A FRIEND TOLD ME ABOUT THE KIA SORENTO ENGINE DEFECT CLASS ACTION LAWSUIT. I BELIEVE MY 2004 KIA SORENTO EX IS AFFECTED BY THIS ENGINE DEFECT. IT WAS DANGEROUS TO BE DRIVING AND I AM THANKFUL I WAS NOT ON A BUSY FREEWAY. AS THIS JUST HAPPENED 3 DAYS AGO, I DO NOT KNOW WHAT I AM GOING TO DO WITH THIS SORENTO. I WOULD LIKE TO HAVE IT FIXED, BUT CANNOT AFFORD TO DO IT. IT IS STILL SITTING IN THE PARKING LOT AT THE MECHANICS IN ST. PETER WHERE AAA TOWED IT TO. *TR
Mar 06, 2015
I PURCHASED A 2004 KIA SORENTO TWO YEARS AGO. IT WAS NOT LONG BEFORE I BEGAN TO EXPERIENCE NUMEROUS PROBLEMS WITH MY VEHICLE. TAIL LIGHTS/BRAKE LIGHTS BURNING OUT FREQUENTLY WHICH IS A MAJOR SAFETY ISSUE SINCE I DELIVER RURAL USDA MAIL. NOW MY TRANSMISSION IS BROKEN!! KIA-DULUTH ASKED IF I HAD HAD THE TRANSMISSION FLUSHED AT THE SPECIFIED MILEAGE AND THAT THEY WILL NEED VERIFICATION OF THIS. (I KNEW IMMEDIATELY THEIR OBJECTIVE WAS TO NOT HONOR THEIR WARRANTY (10 YEARS/100,000 MILE WARRANTY IF I HAD NOT FLUSHED THE TRANSMISSION). I FAXED THEM THE RECEIPT INDICATING THE TRANSMISSION HAD BEEN FLUSHED. I CONTACTED KIA-DULUTH THE FOLLOWING DAY BECAUSE I HAD NOT HEARD FROM THEM. HE SAID HE HAD NOT HEARD BACK FROM KIA YET TO AUTHORIZE THE REPAIR. THIS VEHICLE HAS CAUSED ME SO MUCH LOST WORK TIME, STRESS AND HAS BEEN EMOTIONALLY DRAINING FOR THE PAST TWO YEARS. KIA'S DECEPTIVE ADVERTISING - I BELIEVED THAT SINCE KIA WAS OFFERING A 10 YEAR/100,000 MILE WARRANTY, THEIR VEHICLE MUST BE REALLY GOOD. BOY WAS I WRONG! KIA IS BUILDING VEHICLES WITH DEFECTIVE PARTS AND MATERIALS AND HAS SET-UP THEIR WARRANTY PLAN TO BE ABLE TO VOID THEM FROM HAVING TO HONOR THEIR WARRANTY PLAN AND HAVING ANY RESPONSIBILITY. FOR FURTHER COMPLAINTS ON KIA VEHICLES, PLEASE CONTACT THE BETTER BUSINESS BUREAU AND ATTORNEY GENERAL OFFICES ACROSS THE COUNTRY AND YOU WILL FIND NUMEROUS COMPLAINTS. NUMEROUS COMPLAINTS BY CONSUMERS ARE ALSO LOCATED AT THE FOLLOWING WEBSITES: WWW.MY3CENTS.COM AND WWW.CONSUMERAFFAIRS.COM. KIA NEEDS TO BE INVESTIGATED AND PUT A STOP TO THEIR SCAMMING AND DEFRAUDING THE CONSUMER AND BEFORE SOMEONE GETS SERIOUSLY HURT OR KILLED DUE TO NUMEROUS DEFECTIVE PARTS IN THEIR VEHICLES. *NM
Feb 12, 2007
POWER TRAIN,ENGINE
2 complaints
I HAD THE VEHICLE IN THE DEALERSHIP JUST BELOW 100,000 MILES. THEY DIDN'T BOTHER TO TELL ME THE TRANSMISSION CONTROL MODULE WAS MESSED UP AND NEEDED REPLACED. THIS SEEMS TO BE AN ISSUE WITH SEVERAL PEOPLE. AND THEN TO FIND OUT THIS IS A DEALER ONLY PART AND OVER 900.00! I THINK THIS WAS POOR CUSTOMER SERVICE AND THEY SHOULD'VE KNOWN SOMETHING WAS WRONG. THE GEAR SHIFT WASN'T SITTING IN DRIVE AND NOT SHIFTING CORRECTLY. I DOUBT I'D EVER BUY ANOTHER KIA BECAUSE THEIR SERVICE SUCKS! THEY DON'T VALUE THEIR CUSTOMERS AND THAT REALLY MAKES ME UNEASY. *TR
Jan 16, 2013
WHILE DRIVING ON THE HIGHWAY AT 65 MPH THE CRANKSHAFT BOLT BROKE, THE TIMING BELT AND DRIVE BELT CAME LOOSE. *TR
Jan 10, 2013
ENGINE AND ENGINE COOLING,EQUIPMENT
2 complaints
SHORTLY AFTER I HAD SOME BELTS REPLACED ON MY 2004 KIA SORENTO, THE CRANKSHAFT BOLT BROKE (AROUND 90,000 MILES ON THE VEHICLE). I WAS TOLD THERE WAS A RECALL ON THIS PART, BUT NOT FOR MY VIN NUMBER. I HAD TO PAY OVER $700 TO GET THE PROBLEM FIXED AND MY MECHANIC HAD TO BUY THE PART FROM KIA TO FINALLY GET IT FROM CONTINUALLY BREAKING. NOW, ALMOST TWO YEARS LATER, IT HAS HAPPENED AGAIN (AROUND 130,000 MILES). I CALLED KIA TO SEE IF THEY EXTENDED THE RECALL TO COVER MY VEHICLE, BUT THEY DID NOT AND REFUSED TO DO ANYTHING ABOUT IT. ONCE AGAIN, IT IS COMING OUT OF MY POCKET TO FIX THIS PROBLEM. OBVIOUSLY THIS IS A PROBLEM WITH VEHICLES OTHER THAN THE ONES THAT WERE ORIGINALLY COVERED UNDER THE RECALL. *TR
Jun 08, 2011
I PURCHASED A 2004 KIA SORENTO IN JULY 2004, HAD A FEW PROBLEMS SUCH AS BRAKES WEARING OUT TOO SOON AND THINGS LIKE THAT BUT THE DEALERSHIP WAS GREAT TO MAKE THE REPAIRS AT NO COST. ON MAY 13, 2008 WHILE SITTING OUT A STOP SIGN IN MY NEIGHBORHOOD THE ENGINE BEGAN MAKING A VERY LOUD BANGING NOISE AND THEN STALLED. THE CHECK ENGINE LIGHT CAME ON AND MY IMMEDIATE FEAR WAS THE ENGINE HAD BLOWN. I KNEW THE OIL AND PREVENTIVE MAINTENANCE SERVICE WORK HAD JUST PERFORMED AND NOW THE SERENTO HAD 61K MILES ON IT. I HAD A WRECKER TRUCK TOW THE SERENTO TO THE BAYWAY KIA DEALERSHIP (HOUSTON) WHICH IS WHERE I HAD SERVICE WORK DONE BEFORE. THE NICE SERVICE MANAGER NAMED "JOE' HAD THE ENGINE INSPECTED AND FOUND THE ENGINE FAILED BECAUSE OF A ITEM FALLING OFF THE FUEL INJECTOR INTO A CYLINDER, THUS BLOWING THE ENGINE. "JOE" ADVISED THE ENGINE REPAIR (REPLACEMENT) WOULD BE COVERED UNDER WARRANTY BECAUSE OF A KNOWN DEFECT. NOW IT HAS BEEN 3 MONTHS, STILL NO REPAIR, BAYWAY KIA IS NOW OWNED BY A DIFFERENT COMPANY, THUS "JOE" IS NO LONGER THERE, AND THE KIA DEALERSHIP KEEP STALLING ON THE REPAIR. THEY ONLY HAVE ONE CERTIFIED MECHANIC WHO HAS BEEN SNOWED UNDER WITH WORK. THIS ENTIRE WEEK THE CERTIFIED MECHANIC IS ON VACATION AND TWENTY-FIVE (25) CARS IN THE REPAIR SHOP WAITING ON HIM... HUMMM.... THEY BASICALLY REFUSED TO ALLOW ME TAKING IT TO ANOTHER DEALERSHIP BECAUSE THEY HAVE THE ENGINE TAKEN APART AND ORDERED THE REPLACEMENT PARTS. WHAT GOOD IS A 100K WARRANTY IF THEY KEEP THE VEHICLE FOR MONTHS AND MONTHS, WHILE I STILL PAY THE FINANCE COMPANY? *TR
Jul 25, 2008
ELECTRICAL SYSTEM,EXTERIOR LIGHTING
2 complaints
TL*THE CONTACT OWNS A 2004 KIA SORENTO. THE CONTACT STATED THAT THEY HAD TO REPLACE THE HEADLIGHTS ON THE VEHICLE 74 TIMES. THE CONTACT ALSO STATED THAT THEY HAD TO PURCHASE A NEW BATTERY EVERY YEAR. THE CONTACT STATED THAT EVERY TIME THE VEHICLE HIT A BUMP SHE COULD HEAR THE ELECTRICAL SYSTEM SURGING AND THE LIGHTS BEGAN TO FLICKER. THE DEALER STATED THAT THEY COULD NOT FIND ANYTHING WRONG WITH THE HEADLIGHTS OR THE ELECTRICAL SYSTEM. THE FAILURE AND CURRENT MILEAGES WERE 12000.
Jul 22, 2010
I HAVE A 2004 KIA SORRENTO WITH 57,000 MILES. I HAVE OWNED IT FOR 2 YEARS. THE HEADLIGHTS AND BRAKE LIGHTS CONTINUOUSLY GO OUT. I HAVE REPLACED EACH HEADLIGHT 4 TIMES IN THE PAST YEAR AND THE BRAKE LIGHTS HAVE BEEN REPLACED 5 TIMES IN THE PAST YEAR. THIS IS A SAFETY HAZARD AS I NEVER KNOW WHEN MY BRAKE LIGHTS ARE OUT UNLESS SOMEONE STOPS AND TELLS ME. *TR
Oct 22, 2008
SERVICE BRAKES, HYDRAULIC
2 complaints
ROTORS WARPED. I EXPERIENCE SHUTTERING WHEN STOPPING AT ANY SPEED. I PLAN TO TAKE INTO THE SHOP THIS WEEK FOR REPAIRS. MY FRIEND WITH A JEEP CHEROKEE HAD THE EXACT SAME PROBLEM AND JEEP ISSUED A RECALL. LOOKING AT THE NUMBER OF COMPLAINTS I'VE FOUND ON THIS FOR KIA SORENTO, I FEEL KIA SHOULD TAKE THE SAME ACTION. *TR
Feb 11, 2008
TL*THE CONTACT OWNS A 2004 KIA SORENTO. THE VEHICLE VIBRATES WHEN THE BRAKE IS DEPRESSED AT 40 MPH. THE FRONT ROTORS WERE WARPED AND LATER RESURFACED AT 18,000 MILES. THE VIBRATION DUPLICATED APPROXIMATELY 6,000 MILES AFTER THE RESURFACING. THE DEALER REPLACED THE FRONT ROTORS, HOWEVER THE VIBRATION RECURRED APPROXIMATELY 29,000 MILES LATER. THE DEALER REPLACED THE FRONT ROTORS FOR THE SECOND TIME. PRESENTLY, THE VEHICLE IS BEGINNING TO VIBRATE AGAIN. THE VEHICLE HAS NOT BEEN BACK TO THE DEALER FOR INSPECTION. THE CURRENT AND FAILURE MILEAGE WERE 33,700 MILES.
Mar 19, 2007
ELECTRICAL SYSTEM,STRUCTURE,ENGINE
1 complaint
OCT, 2016 - I AM THE ORIGNAL OWNER OF THE VEHICLE AND HAD MAINTAINED REGULAR MAINTAINENCE ON THE VEHICLE. I HAD JUST PUT $700 OF NEW TIRES ON VEHICLE AND HAD A ROUTINE OIL CHANGE AND FLUID CHECK BEFORE WE LEFT FOR OUR VACATION. I NEVER HAD ANY ISSUES WITH THE VEHICLE AND I STILL OWN. THE VEHICLE DOES NOT RUN BUT I WANTED TO KNOW WHAT STARTED THE FIRE. MY DAUGHTER AND I WERE HEADED OUT OF TOWN FOR A WEEK, ABOUT 200 MILES INTO THE COMMUTE THE FRONT OF THE VEHICLE BEGAN TO SMOKE FROM UNDER THE HOOD, WE WERE TRAVELING AT 55-60 MPH. AS I WAS EXITING THE 421 HIGHWAY FLAMES BEGAN COMING OUT FROM AROUND HOOD AND THE PAINT ON THE HOOD BEGAN TO BUBBLE UP DUE TO HEAT. I IMMEDIATELY CALLED THE FIRE DEPT, AS I WAS DRIVING, PULLED ONTO THE SHOULDER AND IMMEDIATELY REMOVED MY DAUGHTER AND OUR BELONGINGS FROM THE VEHICLE AND DISTANCED OURSELVES FROM THE VEHICLE. WHEN THE FIRE DEPT ARRIVED THEY PUT THE FLAMES OUT AND THE VEHICLE WAS TRANSPORTED TO A LOCAL SHOP, I HAD THE VEHICLE TOWED BACK TO OUR HOME CITY UPON DEPARTURE FROM OUR VACATION. UPON FURTHER OBSERVATION I WAS ABLE TO SEE THE FIRE STARTED IN THE AREA CLOSEST TO WHERE THE ENGINE MEETS THE DASH ON THE DRIVERS SIDE AND CONTINUED TO SPREAD FROM THAT POINT TO THE FRONT OF THE VEHICLE AND UNDER ON THE DRIVERS SIDE.
Oct 17, 2019
VEHICLE SPEED CONTROL,UNKNOWN OR OTHER
1 complaint
I WAS DRIVING WHEN I HEARD A CLUNKING NOISE, AND MY TRUCK SHIFTED. SO I PULLED OVER TO SEE THE MY REAR LOWER ARM FELL FROM SUBFRAME CORRSION DUE TO HEAVY SALT USE HERE IN WI. I HAD TO GET CAR TOWED HOME.
Oct 06, 2019
AIR BAGS,SEAT BELTS
1 complaint
"TAKATA RECALL" I BOUGHT THIS CAR JUST RECENTLY AND THE DRIVERS SIDE AIR BAG STAYS ON ALL THE TIME THERE HAVE BEEN RECALLS BUT NOT ON MY CAR IS IT SAFE TO DRIVE THIS LIKE THIS OR IS IT DANGEROUS AND THE FACTORY SHOULD SEND OUT A RECALL ON THIS RIGHT !
Aug 31, 2019
VEHICLE SPEED CONTROL,ENGINE
1 complaint
UNINTENDED ACCELERATION. RPM WOULD RANGE FROM 1000 TO AS HIGH AS 2000 RPM WITHOUT WARNING. IAC VALVE WAS REPLACED AND DID NOT RESOLVE THE PROBLEM. FINAL DIAGNOSIS WAS CRUISE CONTROL RANDOMLY OPERATING. DISCONNECTED CRUISE CABLE AT THE THROTTLE BODY. PROBLEM CEASED. GREEN LIGHT ON CRUISE SWITCH NEVER INDICATED IT WAS OPERATING. VEHICLE WAS OPERATING AS WELL AS STOPPED AT LIGHTS WHEN THIS OCCURRED.
Aug 13, 2018
STEERING,SERVICE BRAKES,ENGINE
1 complaint
TL* THE CONTACT OWNS A 2004 KIA SORENTO. WHILE DRIVING APPROXIMATELY 30 MPH, THE POWER STEERING AND BRAKES SUDDENLY MALFUNCTIONED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE CAMSHAFT PULLEY WAS FAULTY AND THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER AND THE LOCAL DEALER (QUIRK KIA IN BRANKLY, MA) WERE NOTIFIED OF THE FAILURE, BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 99,000. *LN
Oct 17, 2017
STEERING,POWER TRAIN,ENGINE
1 complaint
I WAS DRIVING OUR 2004 KIA SORENTO WITH MY 3 YOUNG CHILDREN IN THE CAR. DRIVING DOWN A CITY STREET AT 45 MPH THE CAR BEGAN TO JERK AS ALL THE LIGHTS FLASHED ON THE DASHBOARD. I LOST ALL POWER, BUT I WAS ABLE TO CRUISE TO PARK NEXT TO A CURB, HOWEVER THE VEHICLE WOULD NOT RESTART. I HAD IT TOWED TO MY MECHANIC. THE MECHANIC FOUND THAT THE CRANKSHAFT SPROCKET, KEY SHAFT, DAMPER PULLEY, AND CRANK BOLT ALL WERE DAMAGED AND NEEDED TO BE REPLACED.
Jul 06, 2016
ELECTRICAL SYSTEM,EQUIPMENT,ENGINE,FUEL/PROPULSION SYSTEM
1 complaint
TL* THE CONTACT OWNS A 2004 KIA SORENTO. WITHIN LESS THAN 30 DAYS OF OWNING THE VEHICLE, THE CONTACT STATED THAT THE FUEL GAUGE ON THE INSTRUMENT CLUSTER CONTINUED TO INDICATE FULL WHETHER THE CONTACT REFUELED THE VEHICLE OR NOT. ALSO, WHEN THE AIR CONDITIONER WAS TURNED OFF, SMOKE EMITTED INTO THE INTERIOR OF THE VEHICLE AND UNDER THE HOOD. THE CONTACT EXITED THE VEHICLE AND LIFTED THE HOOD TO FAN AWAY THE SMOKE. THE CONTACT DROVE THE VEHICLE TO HER JOB. ANOTHER CONSUMER CALLED THE FIRE DEPARTMENT BECAUSE THE VEHICLE ERUPTED INTO FLAMES. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. NEITHER A FIRE NOR A POLICE REPORT WAS FILED. THE APPROXIMATE FAILURE MILEAGE WAS 107,000. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE.
Mar 18, 2016
EXTERIOR LIGHTING,AIR BAGS
1 complaint
TL* THE CONTACT OWNS A 2004 KIA SORENTO. THE CONTACT STATED THAT WHILE GOING THROUGH INSPECTION, THE AIR BAG WARNING LIGHT ILLUMINATED CONTINUOUSLY. IN ADDITION, THE REAR BRAKE LIGHT FAILED TO OPERATE. THE VEHICLE WAS NOT DIAGNOSED. THE CONTACT STATED THAT THE BRAKE LIGHTS WERE REPAIRED; HOWEVER, THE AIR BAG WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.
Nov 30, 2015
ELECTRONIC STABILITY CONTROL (ESC),ENGINE,FUEL/PROPULSION SYSTEM
1 complaint
200 MILES FROM HOME, OUT OF THE BLUE, CAR ACTED LIKE IT WAS MISFIRING THEN LOST POWER AND DIED ON HIGHWAY AT HIGHWAY SPEEDS. CAR WOULD NOT TURN OVER OR CRANK. CALLED TOW TRUCK TO BRING VEHICLE HOME FOR $490.00 AND MECHANIC CAME OUT AND HOOKED UP MACHINE TO IT AND CODE CAME OUT CRANKSHAFT POSITION SENSOR SYSTEM. CHECK ENGINE LIGHT WASN'T ON AT ALL, UNTIL WE GOT IT HOME AND IT STARTED UP LIKE NO PROBLEM, BUT THEN DIED AGAIN. WEREN'T THE CRANKSHAFT BOLTS ALREADY RECALLED AND FIXED?! MAINTENANCE SCHEDULE ALWAYS KEPT UP TO DATE AND WOULDN'T YOU KNOW, HAPPENED ONE MONTH TO THE DAY THAT MY EXTENDED WARRANTY EXPIRED! STILL HAVEN'T HAD IT TO SHOP, CAN'T AFFORD TO BRING IT IN AFTER HAVING IT TOWED 200 MILES, OTHERS THINKS IT CAN BE FUEL FILTER/PUMP OR THE BRAIN, ECM. WHO KNOWS. SITTING WITH NO VEHICLE IS SO MUCH FUN, THANKS, KIA!
Nov 03, 2015
ENGINE,FUEL/PROPULSION SYSTEM
1 complaint
THREE TIMES THIS WEEK I HAVE BEEN TRAVELING 35 MILES AN HOUR OR LESS AND THE CAR HAS JUST TURNED OFF. THE FIRST TIME I WAS IN A PARKING LOT AND HAD TO PUSH IT INTO A STALL (CRACKING MY TAIL LIGHT WHILE DOING THAT QUICKLY TO GET OUT OF THE WAY.) THE SECOND TIME WAS TURNING A CORNER AND IT DIED. THE THIRD TIME I WAS JUST ENTERING THE FREEWAY ON-RAMP WHEN IT DIED. IT GIVES NO WARNING OTHER THAN SILENCE AND A LAST GASP OF GAS GOING THROUGH. ALL THREE TIMES I WAS ABLE TO STOP THE CAR, PUT IT IN PARK AND RESTART IT. IT HAS BEEN HARDER AND HARDER TO GET IT STARTED AFTER THAT. I TOOK IT INTO THE MECHANIC AND HE CLEANED THE FUEL FILTER, BUT IT HASN'T STOPPED THE PROBLEM TOTALLY.
Oct 10, 2015
EQUIPMENT,ENGINE
1 complaint
TL* THE CONTACT OWNS A 2004 KIA SORENTO. WHILE DRIVING AT APPROXIMATELY 35 MPH, THE VEHICLE LOST POWER AND THE CONTACT HEARD AN ABNORMAL NOISE COMING FROM THE FAN AND AIR CONDITIONER. THE BATTERY INDICATOR WAS ILLUMINATED AND THE VEHICLE STALLED. THE VEHICLE WAS ABLE TO BE RESTARTED. THIS WAS A RECURRING FAILURE. THE CONTACT STATED THAT THE NEIGHBOR ASSISTED HER WITH THE FAILURE BY CHECK UNDER THE ENGINE. IT WAS DISCOVERED THAT THE AIR CONDITIONER BELT FRACTURED, WAS ON TOP OF THE ENGINE BLOCK, AND THE PULLEY WAS LOOSE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE VEHICLE WAS DIAGNOSED AND REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 190,000.
Sep 02, 2015
SUSPENSION,POWER TRAIN,UNKNOWN OR OTHER
1 complaint
ON MONDAY, AUGUST 10TH, 2015 I WAS DRIVING MY 2004 KIA SORENTO LX AND HEARD A LOUD BANG AND THEN THE VEHICLE BEGAN TO FISHTAIL. I WAS TRAVELING AT A LOW SPEED OF AROUND 35 MPH. I IMMEDIATELY SLOWED DOWN AND MANAGED TO DRIVE THE VEHICLE TO A NEARBY GARAGE. AT THE GARAGE THE VEHICLE WAS PLACED ON THE LIFT AND IT WAS IDENTIFIED THAT THE DRIVERS SIDE FRAME RAIL HAD COMPLETELY BROKEN IN HALF AND WAS SEVERELY CORRODED. THE PASSENGER SIDE WAS ALSO SEVERELY CORRODED BUT NOT BROKEN ALL THE WAY THROUGH. THE CROSS-MEMBER ABOVE THE REAR AXLE IS ALMOST COMPLETELY GONE. I NOW HAVE AN 11 YEAR OLD VEHICLE WHICH SHOULD HAVE A RETAIL VALUE OF AROUND $5K WHICH IS NOW COMPLETELY WORTHLESS. I DID SOME INTERNET RESEARCH AND FOUND I AM NOT THE ONLY ONE EXPERIENCING THIS SEVERE CORROSION PROBLEM WITH THIS YEAR AND MODEL KIA. I AM SURPRISED THERE HAVE BEEN NO SAFETY RECALLS FOR THIS PROBLEM. HAD MY INCIDENT HAPPENED AT HIGHWAY SPEEDS THE STORY MAY BE A LOT DIFFERENT.
Aug 25, 2015
POWER TRAIN,UNKNOWN OR OTHER,ENGINE
1 complaint
ABOUT TO GET ON HWY IN NC, RED LIGHT TURNED GREEN STARTED DRIVING NOT EVEN 10 SECONDS LATER GAS PEDAL GOES STRAIGHT TO FLOOR AND SOUNDS LIKE SOMETHING DROPS. IN THE MIDDLE OF THE ROAD CAR JUST STOPS WITH NO WARNING-RIGHT BEFORE MAJOR HWY. TRY TO CRANK THE KIA, NOTHING. AGAIN, NOTHING. PHYSICALLY PUSH THE CAR OFF ROAD WHILE OTHERS ARE SPEEDING BY-ACCIDNET WAITING TO HAPPEN THANK GOD IT DIDNT. GET IT TOWED HOME. SAT IN YARD EVER SINCE. REPLACED MULTIPLE PARTS. STILL DOES NOT RUN..
Aug 19, 2015
POWER TRAIN,ELECTRICAL SYSTEM,ENGINE
1 complaint
I WAS DRIVING APPROXIMATELY 35-40 MPH AND MY CAR SUDDENLY LOST POWER WITH ALL THE DASH LIGHTS BRIEFLY COMING ON (BATTERY, OIL, ETC.). FORTUNATELY I WAS CLOSE TO A SIDE STREET AND WAS ABLE TO MAKE A HARD TURN AND COAST TO THE CURB. I WAITED A MINUTE AND WAS ABLE TO RESTART THE VEHICLE. I DROVE HOME AND THERE WAS ONE MORE INCIDENT WHEN THE CAR STARTED TO LOSE POWER (LIGHTS DIMMED) HOWEVER I PUSHED ON THE GAS AND IT POWERED UP AGAIN. I HAVE HAD THE LIGHTS DIM AND THE CAR SEEMINGLY LOSE POWER SEVERAL TIMES. JUST PRIOR TO THIS THE CAR TYPICALLY HESITATES WHEN YOU ARE GOING FULL SPEED AND THEN THE DIMMING OCCURS. I'VE HAD MY CAR IDLE AT STOP SIGNS AND AT TRAIN CROSSINGS AND HAVE NOT EXPERIENCED ANY POWER LOSS. IT ALWAYS SEEMS TO HAPPEN WHILE DRIVING 35-40 MPH OR MORE. I'VE HAD IT HAPPEN WHILE DRIVING 60-70 MPH ON THE HIGHWAY. I HAD A DIAGNOSTIC RUN ON THE CAR AT THE DEALERSHIP WITH NO CONCERNING RESULTS. I'VE HAD A MECHANIC I TRUST CHECK THE ALTERNATOR, THE SPARK PLUGS, FLUSH THE COOLANT, PUT IN FUEL CLEANER, ETC. AND HE CANNOT LOCATE THE PROBLEM.
Aug 17, 2015
EXTERIOR LIGHTING,VEHICLE SPEED CONTROL,ENGINE
1 complaint
DRIVING DOWN THE ROAD AND ALL OF A SUDDEN I HAVE NO POWER AND CAN NOT GO OVER 25 MPH. HOW SAFE IS THAT ON THE HIGHWAY, ESPECIALLY AS I AM DRIVING WITH MY KIDS!!!?? THIS HAS HAPPENED TWICE. THE 1ST TIME, IT SELF CORRECTED WHEN I WENT TO TAKE IT TO THE DEALER TO LOOK AT. THIS TIME, IT HAS NOT. THE LIGHTS CONSTANTLY GO OFF AND ON AT ANY MOMENTS NOTICE (REAL SAFE WHILE DRIVING AT NIGHT)- AND REMAIN OFF FOR GREAT LENGTHS OF TIME. I HAVE HAD TO REPLACE THE FUSE THAT CONTROLS THE FAN IN THE ENGINE TWICE ALREADY. I WOULD SHUT THE CAR OFF AND THE FAN WOULD NOT TURN OFF UNLESS I POPPED THE HOOD AND PULLED THE FUSE MYSELF AND POCKETED IT UNTIL IT WAS TIME TO DRIVE AGAIN. NOT TO MENTION MAJOR RUST ISSUES ON THE BODY OF THE VEHICLE. THE COSMETIC I CAN DEAL WITH, THE LOSING POWER WHILE ON THE HIGHWAY I CANNOT. IT IS JUST A MATTER OF TIME UNTIL SOMEONE IS VERY SERIOUSLY INJURED, OR KILLED. THE SMELL OF EXHAUST COMES THORUGH THE VENTS, EVEN WITH NORMAL SCHEDULED MAINTENANCE. THIS CAR IS FULL OF DANGERS AND I AM SHOCKED THERE ARE NOT RECALLS OF THESE ISSUES. IN PARTICULAR, THE LOSING POWER WHILE DRIVING, AND THE LIGHTS TURNING ON AND OFF FOR NO REASON. TRY GOOGLING ANY OF THIS AND YOU WILL BE AMAZED HOW MANY PEOPLE ARE DEALING WITH THE SAME ISSUES. UNBELIEVABLE THAT THESE COMPLAINTS HAVE NOT BEEN TAKEN INTO SERIOUS CONSIDERATION. *TR
Mar 05, 2015
ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM
1 complaint
MY 2004 KIA SORENTO HAS AN INTERMITTENT CHECK ENGINE LIGHT THAT DISPLAYS ERROR CODE P0446. THE LIGHT COMES ON AND OFF AS IT PLEASES. THERE IS A TSB FOR THIS PARTICULAR PROBLEM, BUT THERE ARE NO DETAILS. THIS INTERMITTENT LIGHT IS CAUSING MY VEHICLE TO FAIL IT'S SMOG INSPECTION. I HAVE REPLACED THE GAS CAP AS INDICATED BUT THIS DID NOT FIX THE PROBLEM. *TR
Dec 16, 2014
ELECTRONIC STABILITY CONTROL (ESC),FUEL/PROPULSION SYSTEM
1 complaint
MY COMPLIANT WHILE REFUELING THE VEHICLE IT SPILLS BACK OUT FUEL. SPITTING ME, THE SIDE OF THE VEHICLE AND SIDEWALK. CONSTANT ENGINE LIGHT ON. *TR
Oct 12, 2014
STEERING,POWER TRAIN,SERVICE BRAKES
1 complaint
WHILE I WAS DRIVING OUT OF MY COMPLEX MY THE LIGHTS ON THE DASH CAME ON AND IT SEEMED AS IF I LOST MY BRAKES (WHICH I COST TO THE SIDE ROAD AS WELL AS NO STEERING. I HAD THE VEHICLE TOWED AND I WAS TOLD THAT THE PULLEY MOUNTING BOLT HAD BROKEN OFF INSIDE THE CRANKSHAFT. *TR
Sep 27, 2014
STEERING,ENGINE AND ENGINE COOLING
1 complaint
TL* THE CONTACT OWNS A 2004 KIA SORENTO. THE CONTACT STATED THAT THE STEERING WHEEL SEIZED AND EXCESSIVE FORCED WAS REQUIRED. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. THE DEALER REPLACED THE BOLTS. WHILE DRIVING AT VARIOUS SPEEDS, THE BOLTS FRACTURED FROM THE HARMONIC BALANCER. THE VEHICLE WAS TOWED TO THE DEALER WHO INDICATED THAT THE CRANK SHAFT AND ENGINE MIGHT NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 106,000.
Sep 02, 2014
ELECTRICAL SYSTEM,ENGINE
1 complaint
TL* THE CONTACT OWNS A 2004 KIA SORENTO. THE CONTACT NOTICED SMOKE AND FLAMES UNDERNEATH THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THERE WERE NO INJURIES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 161,000.
Aug 11, 2014
SUSPENSION,STRUCTURE,WHEELS
1 complaint
MAJOR RUST PROBLEM WITH FRAME AND SUSPENSION KIA SORENTO PURCHASED MARCH 30 2004 2 MONTHS PAST THE WARRANTY 85392 MILES HAVING JUST DRIVEN ON THE HIGHWAY 65MPH VEHICLE WAS ENTERING SCHOOL PARKINGLOT, AT THE ENTRANCE VEHICLE WENT OVER SPEED BUMP AT THIS POINT THERE WAS A LOUD BANG AND THE VEHICLE STARTED SHAKING AND SQUEALING. UPON INSPECTION THE PASSENGER SIDE REAR STABILIZER-TRACTION BAR BROKE COMPLETELY OFF THE FRAME RAIL JUST FORWARD OF THE WHEEL. THIS CAUSES THE REAR AXEL TO MOVE FREELY FORWARD AND BACK. FURTHER INSPECTION BY KIA DEALERSHIP SHOED MORE COMPONENTS ABOVE THE REAR AXEL BROKEN FREE. I FILED A GOOD WILL COMPLAINT WITH KIA WHO RESPONDED WITH A BIG NO REGARDING ANY HELP. FORTUNATELY THIS BREAKDOWN HAPPENED IN A PARKING LOT AND NO INJURIES HAPPENED BUT IF THIS HAD HAPPENED ON THE HIGHWAY IT WOULD HAVE BEEN A MAJOR ACCIDENT WITH POSSIBLE INJURIES OR DEATH IF THE VEHICLE ROLLED OVER . THIS WAS VERY GOOD LOW MAINTENANCE LOW MILEAGE VEHICLE AND WE WERE HOPING FOR A FEW MORE YEARS OF USAGE, NOW WE ARE DISAPPOINTED WITH KIA THAT NO NOTICES OF MAJOR RUST ISSUES WERE MADE AVAILABLE. NOW WHAT WE HAVE IS A CAR THAT WORTHLESS AND DOESN'T LIVE UP TO THE WARRANTY LIMITS. *TR
Jun 30, 2014
ELECTRICAL SYSTEM,AIR BAGS
1 complaint
BATTERY WAS LOW AND THEN THE AIR BAG WARNING LIGHT WAS ON. THE BATTERY WAS REPLACED AND THE LIGHT STILL ON. LOOKING ONLINE AND FIND OUT THIS ISSUE IS TYPICAL ON ALL KIA SORENTOS. WONDERING WHY THIS ISSUE IS NOT BEING RECALL. CALLED DEALER AND THEY MENTIONED THAT A $130 DIAGNOSE TEST NEEDS TO BE PAID IN ORDER TO KNOW WHAT IS THE PROBLEM. *TR
Jan 13, 2014
FUEL SYSTEM, GASOLINE,STRUCTURE,SERVICE BRAKES
1 complaint
WHILE EXITING MY DRIVEWAY AT HOME (WHICH IS ON A AN INCLINE AND EXITS ONTO A STATE HIGHWAY) I LOST ALL BRAKING CAPABILITY. WHEN I TOOK THE CAR INTO MY LOCAL GARAGE TO HAVE THE PROBLEM DIAGNOSED I WAS TOLD THE BRAKE LINES WERE COMPLETELY CORRODED THROUGH WHICH CAUSED THE LOSS OF BRAKING ABILITY. WHILE ATTEMPTING THE REPAIRS THE MECHANIC SMELLED GASOLINE FUMES AND FOUND THAT THE FUEL LINES WHERE THEY EXIT THE TANK HAS ALSO CORRODED THROUGH. I STARTED TO NOTICE UNDER BODY CORROSION SEVERAL YEARS AGO WHEN THE PARKING BRAKE BODY ATTACHMENT POINTS ON THE REAR DIFFERENTIAL CORRODED AND BECAME DISLODGED. ALL OF THIS CORROSION SEEMS TO BE OCCURRING MUCH SOONER THAN I WOULD EXPECT AND SOONER THAN I HAVE EVER EXPERIENCED WITH OTHER VEHICLES I HAVE OWNED MANUFACTURED BY OTHER COMPANIES. *TR
Sep 09, 2013
SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE,POWER TRAIN,VEHICLE SPEED CONTROL
1 complaint
WE PURCHASED OUR SORENTO USED (APPROX 65K MILES)ABOUT 3 YEARS AGO. SINCE THEN, WE'VE HAD TO REPLACE THE GAS TANK ($1500) AMONG OTHER THINGS. THIS YEAR HAS BEEN ABSURD: HAD TO REPLACE THE RADIATOR, WATER PUMP, COMPUTER SYSTEM (2 MONTHS, $4700), BRAKES ($750) AND 2 BATTERIES. 2-3 MONTHS AGO, WE NOTICED A CLUNKING/CHUNKING SOUND THAT GREW STEADILY WORSE. IT SOUNDED AS IF THE 4WD WAS ENGAGING AND DISENGAGING EVERY 3 SECONDS AND FELT VERY UNSAFE AT HIGH SPEEDS. I TOOK IT TO KIA OF COBB COUNTY AND WAS JUST GIVEN A QUOTE FRIDAY FOR A NEW TRANSFER CASE, DRIVE SHAFT, "REAR END CHUNK" (ALL THE SERVICE REP COULD TELL ME) AND 4 NEW TIRES. QUOTE FOR THIS WORK ($9767). THE TRANSFER CASE ALONE WAS AROUND $5700. THIS VEHICLE NOW HAS 112K MILES AND IS LESS THAN 10 YEARS OLD. THE BLUE BOOK VALUE IS (WAS) AROUND $5-6000 AND WE'RE TOLD IT'LL TAKE $10,000 TO FIX IT? I CALLED KIA'S CORPORATE OFFICE TO ASK IF THIS WAS TO BE EXPECTED AT KIA. I WAS TOLD THAT OUR VEHICLE WAS NOT UNDER WARRANTY. I SAID, " I'M JUST ASKING IF THERE'S ANYONE AT KIA HEADQUARTERS WHO BELIEVES IN THEIR PRODUCT AND WANTS TO PROTECT THE KIA NAME AND YOU JUST KEEP APOLOGIZING." THE REP RESPONDED, "I'M SORRY, SIR." WE'VE FOUND MULTIPLE COMPLAINTS ONLINE FROM KIA OWNERS REPORTING SIMILAR ISSUES (CHUNKING, TRANSFER CASE, ETC). WHEN DOES THIS BECOME.A RECALL ISSUE? A SAFETY ISSUE? *TR
Aug 12, 2013
POWER TRAIN,SERVICE BRAKES
1 complaint
ENTERING I-35 NORTH FROM ACCESS ROAD IN SAN ANTONIO TEXAS. TIME 08:15AM (RUSH HOUR) LOUD BANG FROM REAR OF VEHICLE SPEED IMMEDIATELY DROPPED TO 20MPH, INITIALLY THOUGHT I HAD BLOWN A TIRE. PULLED OFF ACCESS ROAD TO SIDE STREET. WAS HAVING TROUBLE STOPPING VEHICLE NO BRAKE PRESSURE FOOT WENT ALL THE WAY TO FLOORBOARD. CHECKED REAR TIRES, NO VISIBLE DAMAGE TO EITHER TIRE (TIRES WERE NEW)WHEN VEHICLE WAS PURCHASED. AGAIN ATTEMPTED TO DRIVE VEHICLE, REAR TIRES WERE HAVING TROUBLE ROTATING? LATER DISCOVERED WHEEL BEARINGS HAD FAILED. *TR
Feb 12, 2013
SUSPENSION,ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM,VISIBILITY/WIPER
1 complaint
PICKED UP VEHICLE AFTER HAVING REAR SUPPORT BEARINGS REPAIRED DRIVING BACK HOME AT 65MPH ON I-35/TEXAS 410 EAST STARTED TO EXPERIENCE STRONG SMELL OF EXHAUST FUMES IN PASSENGER COMPARTMENT. DURING DRIVE HOME STARTED TO RAIN, ACTIVATED WIPERS, DRIVERS SIDE WIPER BLADE FELL OFF DURING RAINSTORM HAD TO OPEN DRIVER SIDE WINDOW TO NAVIGATE! UPON ARRIVAL AT HOME NOTICED, SMOKE COMING FROM ENGINE COMPARTMENT (PASSENGERS SIDE) AND SMOKE UNDERNEATH VEHICLE FROM CATALYTIC CONVERTER. LOOKED UNDERNEATH VEHICLE AND CATALYTIC CONVERTER, WAS SMOKING, INSIDE ENGINE COMPARTMENT A HOSE AT THE REAR OF THE ENGINE COMPARTMENT (SORRY NOT A MECHANIC) HAD A HOLE IN IT AND WAS SMOKING ALSO? VEHICLE HAS NOT BEEN DRIVEN SINCE 12/7/12, VEHICLE WAS PURCHASED 10/4/12, HAS LIMITED WARRANTY. *TR
Feb 12, 2013
STEERING,POWER TRAIN
1 complaint
WE HAVE HAD 4 INSTANCES WITH THE SAME ISSUE IN THE FIXING THE PULLEY CRANK SHAFT. JUNE 30, 08, (RECALL) OCTOBER 6, 09, AUG 10, 10 AND ONCE AGAIN SEPT 18,12. THIS IS THE SAME ISSUE THAT CAUSES YOU TO LOOSE STEERING WHILE DRIVING WITH APPARENTLY NO WARNING. I FIND THIS EXTREMELY TROUBLING AS WE HAVE A NEW DRIVER LEARNING WITH THIS CAR. WE ARE LUCKY TO REPORT THAT THERE HAVE BEEN NO ACCIDENTS OR DEATHS BUT I THINK IT IS A VERY DANGEROUS SITUATION THAT WILL SOON HAPPEN. THE DEALER WAGNER KIA OF SHREWSBURY,MA FEELS THAT IT IS NOT AN ISSUE AND IS JUST FROM WEAR AND TEAR. 4 TIMES FOR THE SAME PROBLEM? OBVIOUSLY KIA HAS NOT FIXED THE PROBLEM CORRECTLY. IT ANGERS ME THAT KIA IS NOT TAKING THIS SERIOUSLY. WE DRIVE OUR CHILDREN AS WELL AS OTHER CHILDREN IN THIS CAR AND COULD OF HAD SERIOUS TO FATAL INJURIES. FROM THIS BOLT SHEARING OFF IT HAS ALSO CAUSED OTHER MAJOR DAMAGE TO THE CAR THAT WE HAVE ALREADY HAD FIXED. *TR
Sep 20, 2012
SUSPENSION,ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE,POWER TRAIN,ELECTRICAL SYSTEM,EXTERIOR LIGHTING
1 complaint
SUMMARY: UPDATE TO BELOW PROBLEM I BOUGHT MY SORENTO IN 2004, NEW. I REPLACED THE COOLANT RESERVOIR AT 61000 MILES DUE TO OVERHEATING, REPLACED THE LOW BEAM HEADLIGHT BULBS ON 4 OCCASIONS, TAIL LIGHTS ON 2 OCCASIONS. MY VEHICLE, 5 SPEED MANUAL TRANSMISSION, STARTED TO HAVE A ROARING NOISE APPROX. 6 MONTHS AGO AND THE U-JOINTS WERE REPLACED. IT STILL ROARS. IT QUIT RUNNING ON 2-16-12 WHILE I WAS DRIVING, BUT RESTARTED. IT FINALLY QUIT AGAIN AND WOULD NOT RESTART ON 2-17-12. CHECK ENGINE LIGHT INDICATE A FUEL PRESSURE SENSOR PROBLEM, BUT MECHANIC SAYS THIS SHOULD NOT CAUSE THE PROBLEM I PRESENTLY HAVE. IT HAS BEEN IN THE SHOP SINCE 2-18-12. THE MECHANIC SAID IT STARTED FOR HIM. I INSISTED HE LET IT RUN FOR A WHILE AND SEE WHAT HAPPENS. SURE ENOUGH, IT QUIT. KIA MECHANIC TOLD ME IT MAY BE A CRANK OR CAM SENSOR ISSUE. OTHER PROBLEMS--FRONT DOME LIGHT OFF AND ON AT WILL, REAR ONE WORKS, CLOCK ON AND OFF AT WILL, VEHICLE HUMS LOUDLY WHEN DRIVING FOR A WHILE. IT HAS BEEN A RELIABLE VEHICLE FOR THE MOST PART, BUT WHEN THERE IS AN ISSUE, IT IS HARD TO DETECT. ABOVE WORK WAS COMPLETED AT A COST OF 1126,00. BUT NOW CRANKSHAFT BOLT BROKE WHILE DRIVING COSTING DAMAGE TO ENGINE HEADS. VEHICLE WENT BACK INTO SHOP AND IS STILL WAITING REPAIRS. KIA OWES IT CUSTOMERS BETTER SERVICE AND MUST PAY REPAIR COST AND TAKE RESPONSIBILITY FOR THE FAULTY CRANKSHAFT BOLTS THEY PROVIDE TO THE MECHANICS . *TR
Apr 03, 2012
ENGINE AND ENGINE COOLING,POWER TRAIN,EXTERIOR LIGHTING
1 complaint
I BOUGHT MY SARENTO IN 2004, NEW. I REPLACED THE COOLANT RESERVOR AT 61000 MILES DUE TO OVERHEATING, REPLACED THE LOW BEAM HEADLIGHT BULBS ON 4 OCASIONS, TAIL LIGHTS ON 2 OCASIONS. MY VEHICLE, 5 SPEED MANUAL TRANSMISSION, STARTED TO HAVE A ROARING NOISE APPROX. 6 MONTHS AGO AND THE U-JOINTS WERE REPLACED. IT STILL ROARS. IT QUIT RUNNING ON 2-16-12 WHILE I WAS DRIVING, BUT RESTARTED. IT FINALLY QUIT AGAIN AND WOULD NOT RESTART ON 2-17-12. CHECK ENGINE LIGHT INDICATE A FUEL PRESSURE SENSOR PROBLEM, BUT MECHANIC SAYS THIS SHOULD NOT CAUSE THE PROBLEM I PRESENTLY HAVE. IT HAS BEEN IN THE SHOP SINCE 2-18-12. THE MECHANIC SAID IT STARTED FOR HIM. I INSISTED HE LET IT RUN FOR A WHILE AND SEE WHAT HAPPENS. SURE ENOUGH, IT QUIT. KIA MECHANIC TOLD ME IT MAY BE A CRANK OR CAM SENSOR ISSUE. OTHER PROBLEMS--FRONT DOME LIGHT OFF AND ON AT WILL, REAR ONE WORKS, CLOCK ON AND OFF AT WILL, VEHICLE HUMS LOUDLY WHEN DRIVING FOR A WHILE. IT HAS BEEN A RELIABLE VEHICLE FOR THE MOST PART, BUT WHEN THERE IS AN ISSUE, IT IS HARD TO DETECT. *TR
Feb 22, 2012
SUSPENSION,POWER TRAIN,WHEELS
1 complaint
VEHICLE IS ONLY 7 YEARS OLD. METAL BRACKET WELDED TO THE REAR AXLE THAT HOLDS THE UPPER CONTROL ARMS HAS COMPLETELY FAILED! THE NORMAL TORQUE FROM THE REAR AXLE HAS BROKEN BOTH BRACKETS HOLDING THE UPPER CONTROL ARM TO THE CARS FRAME. ALL THAT IS HOLDING THE REAR AXLE IN PLACE IS THE LOWER CONTROL ARMS AND THE SWAY BARS. THERE ARE NO WEEP HOLES TO ALLOW WATER TO DRAIN OUT OF THE BRACKET WELDMENT, CAUSING WATER TO FILL THE CUP-LIKE CONDITION CREATED. THIS CONDITION HAS (AN WILL) CAUSE PREMATURE FAILURE OF ALL KIA SORENTO REAR AXLE/UPPER CONTROL ARM CONNECTIONS. WHILE DRIVING THE REAR AXLE COULD BECOME DETACHED FROM THE VEHICLE DUE TO EXCESSIVE STRESS PLACED ON THE REMAINING PARTS. A TYPICAL TRAFFIC MANEUVER COULD CAUSE A CATASTROPHIC FAILURE, AND RENDER THE VEHICLE UNCONTROLABLE, WITH THE LIKELYNESS OF MASSIVE PAIN, INJURY AND DEATH AS A RESULT!!! THIS IS AN EXTREMELY DANGEROUS CONDITION!!! THESE CARS NEED TO BE RECALLED NOW BEFORE SOMEONE IS KILLED!!! PS IF YOU SEE A KIA SORENTO ON THE FREEWAY...STAY AWAY FROM IT FOR YOUR OWN SAFETY!
Dec 03, 2011
FUEL SYSTEM, GASOLINE
1 complaint
I AM WRITING THIS COMPLAINT AGAINST KIA MOTORS WHO WILLINGLY KNOWS OF ISSUES WITH ITS FUEL SYSTEMS IN ALL 2004 KIA SORENTOS. EVEN LOOKING ONLINE YOU SEE THOUSANDS OF KIA OWNERS WHO HAVE HAD THE SENSOR GO OUT ON THIS MODEL CAR AFTER THE CARS 100000 WARRANTY, AND THEN KIA CLAIMS IT IS PAST THE WARRANTY THEY HAVE AND THERE IS NOTHING THEY CAN DO. THIS CAUSES THE GAS TO ALWAYS READ INCORRECTLY EVEN WITH A FULL TANK THE CAR READS "E" AND CONTINUOUSLY EVERY DAY HAVE TO PLACE MORE GAS IN CAR FOR FEAR THAT THE "E" MAY COME ON AND LIKE SEVERAL DAYS AGO I WAS LEFT ON THE SIDE OF THE ROAD FROM THIS. WHEN YOU REACH OUT TO KIA THEY OFFER NO HELP STATING THERE ARE NO DOCUMENTED CASES AND WHEN YOU TELL THEM TO LOOK ONLINE, THEY CLAIM THOSE COULD JUST BE ANGRY CUSTOMERS PLACING FALSE INFORMATION. THEN THEY WANT TO HANG BEHIND THE "AS IS" CLAUSE STATING THAT I SHOULD HAVE HAD A MECHANIC CHECK THE CAR OUT, WHICH UNLESS THEY ARE A KIA DEALER AND ARE AWARE OF THIS ISSUE WHICH DID NOT SHOW UP TO SEVERAL DAYS LATER AFTER THE CAR WAS PURCHASED. THIS IS KNOWN DEFECT IN MANUFACTURING AS EVIDENCED ONLINE AND FEEL THAT SOMETHING SHOULD BE DONE TO MAKE KIA FIX THESE PROBLEMS WITHOUT CUSTOMERS HAVING TO FORK OVER MORE AND MORE MONEY OVER SOMETHING KIA ITSELF IS RESPONSIBLE FOR AND WILL NOT RECTIFY. *TR
Aug 25, 2011
FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM
1 complaint
REPEATED PROBLEMS WITH CHECK ENGINE LIGHT, KEEP GIVING EVAP CODE, REPLACED EVAP CANISTER SOLENOID WITH KIT, HEADLIGHTS, TAILLIGHTS, CLOCK LOSES TIME, . *TR
Jul 08, 2011
STRUCTURE,UNKNOWN OR OTHER
1 complaint
ON THE ABOVE MENTIONED DATE THE VEHICLE WAS TAKEN TO NTB FOR A 90,000 MILE CHECK AND TO REPLACE A BOLT THAT HAD BROKEN LOOSE IT WAS LOCATED NEAR THE REAR AXLE WHEN PUT UP ON THE LIFT A VERY DANGEROUS SITUATION WAS REVEALED. THE FRAME ABOVE THE REAR AXLE HAD COMPLETELY ROTTED WHICH CAUSED THE BOLT TO BREAK AND THE RESULTING LOSS OF INTEGRITY CAUSED WEAKENING AND AND BOUNCING CAUSING THE GAS TANK TO BE PUNCTURED. THE CAR WAS DEEMED UNDRIVABLE. I HAVE WRITTEN TO KIA WITH NO RESPONSE THE CAR HAD BEEN RELIABLE AND WAS TAKEN CARE OF THIS PUT US IN A TOUGH FINANCIAL SITUATION HAVING TO BUY ANOTHER CAR IN OUR AREA ALONE THERE ARE TWO KIA,S THAT HAD ROTTING FRAMES ONE THE SAME YEAR AND MAKE AS OURS HIS HAD 106,000 MILES THE ROTTING WAS NOT NEAR AS BAD AS OURS BUT THE SAME BOLT BROKE OFF ANOTHER WAS A DIFFERENT MODEL BUT HE HAD TO GET THE FRONT AXLE REPLACED BECAUSE OF ROTTING OUR FAMILY WAS PUT IN A VERY DANGEROUS SITUATION WE COULD HAVE BEEN KILLED THE FRAME OF THE CAR IS ABOUT THE LAST THING YOU WOULD EXPECT TO FAIL KIA IS SAYING THAT IT IS ANTIPERFORATION AND NOT COVERED ANTIPERFORATION HAS NOTHING TO DO WITH THE FRAME ANYTHING YOU CAN DO TO HELPWOULD BE APPRECIATED I AM FILING THIS ON BEHALF OF MY DAUGHTER
May 25, 2011
ENGINE AND ENGINE COOLING,POWER TRAIN,ELECTRICAL SYSTEM,AIR BAGS,EQUIPMENT
1 complaint
I BOUGHT A 2004 KIA SORENTO IN 2006 FINISHED PAYING FOR IT IN 2010,OVER THE YEARS I HAVE HAD TO CHANGE THE LIGHTS SO MANY TIMES I CANT COUNT,I HAVE HAD TOPAINT IT TWICE,THEN THE DRIVING SHAFT BROKE,THE COMPRESSOR WAS CHANGED TWICE, THE CD PLAYER WORKS ON AND OFF THE AIR BAGS LIGHT CAME ON AND STAYED FOR MONTHS ON END THE ENGINE LIGHT DOES THE SAME AND MOST RECENTLY THERE IS SMOKE COMING FROM THE ENGINE, I AM HAVING TO STOP PARK AND LET IT COOL OFF BEFORE CONTINUING ON MY JOURNEY, AT THE MOMENT I GOT SCARED AND I NOW I HAVE MY VEHICLE PARKED AT HOME BECAUSE I AM SCARED TO DRIVE IT, IT IS A SHAME AND I AM VERY UPSET. IS THERE ANYONE OUT THERE WHO IS TRYING TO DO SOMETHING ABOUT THESE PROBLEMS US CONSUMERS ARE HAVING? I OWN MY VEHICLE AND HAS A CLEAN TITLE AND WOULD LIKE TO TRADE IN OR SELL BUT WITH ALL THESE PROBLEMS HOW CAN I PASS IT ON TO SOMEONE ELSE? I AM ASKING SOMEONE FROM KIA TO DO THE RESPONSIBLE THING AND GIVE US SOME ANSWERS BEFORE SOMEONE LOSES THEIR LIFE,THAT IS IF IT HASN'T HAPPENED ALREADY. DON'T LET THIS BE TOYOTA. *TR
Mar 23, 2011
ENGINE AND ENGINE COOLING,VISIBILITY
1 complaint
I BOUGHT MY 2004 SORENTO NEW. IN MAY 2008 AND AT 64,000 MILES THIS YEAR THE WATER PUMP STARTED LEAKING. I TOOK IT INTO THE LOCAL KIA DEALERSHIP AND THEY SAID IT WAS UNDER A RECALL AND REPLACED IT. THEY ALSO RECOMMENDED A TIMING BELT CHANGE AT THAT TIME AND I DID THAT TOO. AFTER I LEFT THE DEALERSHIP AND DROVE INTO MY GARAGE, WATER WAS POURING OUT FROM UNDERNEATH THE PASSENGERS SIDE TIRE, WHERE THE RESERVE TANK WAS. I TURNED AROUND TOOK IT RIGHT BACK AND SHOWED THEM. THEY SAID IT WASN'T ANYTHING THEY DID TO BUST IT, IT MUST OF BEEN THAT WAY ALREADY. I INFORMED THEM THAT I KNOW IT WASN'T THAT WAY BECAUSE I HAD BEEN POURING TONS OF WATER IN IT UNTIL I COULD GET MY CAR IN FOR THAT APPOINTMENT SINCE THE WATER PUMP WAS LEAKING AND THE LEAKING BEFORE WAS COMING FROM THE CENTER OF THE CAR, NOT BY THE TIRE. I ALSO INFORMED THEM, THAT I KNEW THEY BUSTED BECAUSE THEY HAD TO PUT PRESSURE ON THE WATER PUMP LINE TO TEST IT AND THEREFORE IT WAS THERE FOUGHT. THEY STILL SAID EVEN THOUGH THEY DIDN'T DO IT THEY WOULD GO AHEAD AND REPLACE IT FOR FREE. WHY DO THEY NOT WANT TO OWN UP TO IT TO BEGIN WITH? IF I HAD NOT MADE A SCENE IN FRONT OF THEIR OTHER CUSTOMERS THEY WHERE GOING TO MAKE ME PAY FOR IT. I HAVE ALSO HAD THE WIPER PARK AREA BURN OUT. SMOKE STARTED COMING FROM MY WINDSHIELD ON HE INSIDE AND NOW THE HEATED WIPER PARK AREA IS NOT WORKING. IT WILL NEED A WHOLE NEW WINDSHIELD. *TR
Dec 13, 2008
ENGINE AND ENGINE COOLING,AIR BAGS,STRUCTURE
1 complaint
TL*THE CONTACT OWNS A 2004 KIA SORENTO. WHILE DRIVING APPROXIMATELY 30 MPH ON NORMAL ROAD CONDITIONS, THE ENGINE STALLED UNEXPECTEDLY AND RESTARTED AFTER SEVERAL ATTEMPTS. THE CHECK ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL AND REMAINED LIT UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY STATED THAT THE MANIFOLD GASKET FAILED. THE VEHICLE WAS REPAIRED UNDER WARRANTY. ON SIX SEPARATE OCCASIONS, THE VEHICLE WAS TAKEN BACK TO THE AUTHORIZED DEALER FOR IDENTICAL FAILURES, BUT THERE WERE NO RESOLUTIONS. THE CONTACT WAS RESPONSIBLE FOR THE REPAIR EXPENSE BECAUSE THE WARRANTY EXPIRED. THE AUTHORIZED DEALER REPLACED THE CRANKSHAFT, CRANKSHAFT SENSOR, TIMING BELT, AND DRIVE BELT. THE FAILURE MILEAGE WAS 50,000 AND CURRENT MILEAGE WAS 66,000. UPDATED 12/23/08 THE AIR BAG ILLUMINATED AND WOULD NOT GO OUT, EVEN WHEN SOMEONE WAS SEATED IN. THE HEADLIGHT WAS BLOWN, THE REAR HATCH WOULD NOT STAY UP. THE DEALER HAD TO ORDER HOOD STRUTS. UPDATED 12/23/08.*JB
Nov 28, 2008
ENGINE AND ENGINE COOLING,POWER TRAIN,ELECTRICAL SYSTEM,EXTERIOR LIGHTING,VISIBILITY,STRUCTURE
1 complaint
MY SISTER PURCHASED THIS VEHICLE NEW AND HAS HAD NOTHING BUT PROBLEMS WITH IT AND PROBLEMS WITH DEALERSHIP/KIA HONORING THEIR 10 YEAR/100,000 MILE WARRANTY. SHE PURCHASED THIS VEHICLE BELIEVING SHE WOULD BE DRIVING A QUALITY VEHICLE (ADVERTISING 10 YEAR/100,000 MILE WARRANTY SHE ASSUMED IT MUST BE OF HIGH QUALITY BECAUSE WHO WOULD OFFER THAT KIND OF WARRANTY IF IT WAS JUNK....WRONG!) SHE HAS HAD NOTHING BUT STRESS, FINANCIAL EXPENSE, LOST WORK TIME, AND A BATTLE OF HER LIFE TRYING TO SEEK CONSUMER JUSTICE...DEALERSHIP, KIA MOTORS, LEMON LAW REQUIRES A PART TO FAIL FOUR TIMES, ATTORNEY GENERALS OFFICE, CONCILIATION COURT, WRITING TO RUUKIVINA, OBERSTAR, AND MOST RECENTLY AMY KLOBUCHAR...ALL FAILED. NO ONE HAS SAID THAT THEY WILL INVESTIGATE KIA AND PROTECT THE CONSUMERS FROM THIS FRAUDULENT AUTOMOBILE MANUFACTURER. WHY? THE PROBLEMS SHE HAS HAD WITH HER VEHICLE CONSIST OF RUST ON THE TAILGATE AND REAR DOORS JUST A FEW MONTHS AFTER PURCHASING, ALL KINDS OF ELECTRICAL PROBLEMS FROM HEADLIGHTS AND TAIL LIGHTS BURNING OUT NUMEROUS TIMES, THE DIGITAL DASH FOR RADIO AND HEATER GOING BLACK, THE HEATER NOT WORK, A RELAY SWITCH FOR FAN FAILED, FOAM BETWEEN WINDSHIELD AND FRAME COMING OUT TAPPING ON THE WINDOW, A PROBLEM WITH THE COOLANT RESERVOIR, THE REAR DRIVESHAFT FAILED, THE TRANSMISSION HAD TO BE REPLACED AND MOST RECENTLY THE TRANSFER CASE. SAFETY ISSUES AND CONCERNS WOULD BE WITH TAIL LIGHTS AND HEADLIGHTS BURNING OUT PREMATURELY AND FREQUENTLY AND THE CRANKSHAFT BOLT BROKE CAUSING TO LOOSE ALL ABILITY TO STEER THE VEHICLE. THERE ARE PROBABLY OTHER PROBLEMS SHE HAS HAD WITH THE VEHICLE BUT I DO NOT RECALL AT THIS TIME. *TR
Aug 14, 2008
STEERING,ELECTRICAL SYSTEM
1 complaint
ON MONDAY, 06-30-08, AT ABOUT 1400 HOURS, I PARKED MY VEHICLE A 2004 KIA SORRENTO 4X4 EX WITH APPROX. 80,000 PLUS MILES. SHORTLY AFTER PARKING THIS VEHICLE I ENTERED A BASKIN AND ROBINS TO HAVE AN ICE CREAM CONE. I WAS INFORMED BY FRANTIC PASSERBY'S THAT A VEHICLE WAS ON FIRE. I TOOK A LOOK OUTSIDE AND WAS SHOCKED TO SEE THAT MY VEHICLE MENTIONED ABOVE WAS SMOKING AND FLAMING UP. THIS FIRE APPEARED TO START ON THE PASSENGER SIDE OF MY VEHICLE NEAR THE POWER STEERING PUMP AND ALTERNATOR. MY VEHICLE HAD BEEN OPERATING FINE UNTIL THIS INCIDENT OCCURRED AND ONLY WENT TO THE DEALERSHIP FOR ROUTINE SERVICING UNDER WARRANTY. THE HONOLULU POLICE AND FIRE DEPARTMENTS WERE NOTIFIED AND REPORTS DOCUMENTED UNDER HONOLULU POLICE DEPARTMENT REPORT #08-242969 AND THE HONOLULU FIRE DEPARTMENT REPORT #24891. FIRE AND POLICE OFFICIALS INFORMED ME THAT A POSSIBLE FUEL LINE MALFUNCTION IS A POSSIBILITY BUT CAUSE OF THIS INCIDENT IS UNKNOWN AT THIS TIME. *TR
Jul 03, 2008
ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM
1 complaint
I HAVE A 2004 KIA SORRENTO WHICH I PURCHASED NEW. IT CURRENTLY HAD 64,000 MILE AND I HAVE KEPT UP WITH ALL MAINTENANCE ITEMS AND HAVE HAD THEM PERFORMED BY KIA SERVICE IN THE DEALERSHIP. WHILE I HAVE HAD SOME MECHANICAL PROBLEMS WITH THE CAR (BAD LIFTERS, VALVES, RADIATOR LEAKS, ETC), MY MAIN ISSUE IS THE ELECTRICAL SYSTEM. TO DATE, I HAVE REPLACED VARIOUS BRAKE LIGHT BULBS, HEADLIGHT BULBS, DOME LIGHT BULB AND MY RADIO UNEXPLAINABLE TURNS ON/OFF. WHILE I HAVE DEALT WITH THESE ISSUES AS THEY ARISE, MY CAR HAS NOW TURNED OF WHILE DRIVING ON THE ROAD TWICE. ON BOTH OCCASIONS, ALL OF THE CAR LIGHTS, DISPLAYS, ETC, TURN OFF COMPLETELY AND THE CAR SIMPLY COASTS WHILE OFF. ONE OF THE OCCURRENCES I WAS ON THE INTERSTATE GOING 65 MPH, AND THE CAR SHUT DOWN. BOTH TIMES I PULL TO THE SIDE OF THE ROAD AND WHEN I TURNED THE KEY, IT STARTED AGAIN. MY OBVIOUS CONCERN IS THAT OF SAFETY AS IT RELATES TO THE VARIOUS ELECTRICAL PROBLEMS (WHICH ARE NO LONGER COVERED UNDER WARRANTY) WHICH THIS CAR HAS HAD. WHILE I CANNOT SPEAK FOR OTHER KIA OWNERS, THERE ARE A HOST OF FORUMS WHICH RELATE TO SIMILAR ISSUES. ADDITIONALLY, THE DEALERSHIPS THEMSELVES ARE AWARE OF THE ELECTRICAL ISSUES, AS NOTED TO ME PERSONALLY BY ONE OF THE TECHNICIANS. I AM REQUESTING FOR KIA TO PROVIDE THE LEVEL OF CUSTOMER SERVICE WHICH WE (AS KIA OWNERS) HAVE EXPECTED. THE ELECTRICAL PROBLEMS ARE WELL DOCUMENTED AND SHOULD BE ADDRESSED. FURTHERMORE, I AM LOOKING FOR ASSISTANCE IN MY PERSONAL SITUATION NOW THAT MY CAR IS ONLY 4,000 OUT OF WARRANTY AND HAS THE ELECTRICAL ISSUES AND MORE IMPORTANTLY THE HAZARDOUS PROBLEM OF SHUTTING DOWN. I AM MORE THAT HAPPY TO PROVIDE ANY RECORDS WHICH WILL DOCUMENT THE PROBLEMS DETAILED ABOVE. ALSO, I AM AVAILABLE ANYTIME TO DISCUSS FURTHER IF NEEDED. THANK YOU IN ADVANCE FOR YOUR CUSTOMER SERVICE. *TR
Jan 18, 2008
STEERING,SUSPENSION
1 complaint
TL*THE CONTACT OWNS A 2004 KIA SORENTO. WHILE DRIVING 15 MPH, THE STEERING WHEEL FAILED TO TURN TO THE RIGHT AND THE VEHICLE CRASHED INTO A POLE. THE FENDER WAS BADLY DAMAGED AND THE VEHICLE WAS TOWED TO THE LOCAL DEALER. THE DEALER STATED THAT THE VEHICLE NEEDED A NEW RACK AND PINION, TIE ROD, UPPER AND LOWER BALL JOINT ASSEMBLY, STEERING KNUCKLE, AND A PASSENGER SIDE FRONT WHEEL. THE CURRENT AND FAILURE MILEAGES WERE 38,000.
Sep 07, 2007
ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM,EXTERIOR LIGHTING
1 complaint
2004 KIA SORENTO - LOSS OF POWER, BRAKE AND BATTERY LIGHTS ILLUMINATED, VEHICLE STALLED. CRANK BOLT FAILURE. HAPPENED 3 TIMES; REPLACED/FIXED 3 TIMES. A LETTER TO KIA BEING SENT AT THE TIME THIS WAS BEING WRITTEN.*AK
Apr 14, 2007
ELECTRICAL SYSTEM,EXTERIOR LIGHTING,STRUCTURE
1 complaint
IN LESS THAN A YEAR CONSUMER HEADLIGHT WENT OUT AND THE BACK HATCH WINDOW WAS LEAKING INSIDE THE VEHICLE EVERY TIME IT RAINED. *TS THE HEADLIGHT ASSEMBLY WAS REPLACED ON NOVEMBER 30, 2004 AND FIVE MINUTES AFTER THE NEW BULB WAS INSTALLED IT SHATTERED. ON THAT SAME DATE THE CONSUMER EXPERIENCED PROBLEM WITH THE CLOCK AND HVAC INDICATORS. UPDATED 03/30/07. *JB
Oct 07, 2005
SEATS
1 complaint
A FEW WEEKS AFTER PURCHASING MY 2004 KIA SORENTO, I NOTICED THE DRIVERS SEAT ROCKING BACK AND FORTH WHEN ACCELERATING AND BRAKING. DEALER REPLACED SEAT RAIL. THAT FAILED TO RESOLVE PROBLEM. SINCE THEN THE DEALER HAS AGAIN REPLACE THE SEAT RAIL AND THE WHOLE SEAT WITHOUT RESOLVING THE PROBLEM. KIA REP SAYS THAT IT IS NORMAL FOR ELECTRIC SEATS IN KIAS TO ROCK LIKE MINE DOES. I BELIEVE THE SEAT WILL EVENTUALLY FAIL DURING AN ACCIDENT RENDERING IT AND THE SEAT BELT USELESS.*AK
Aug 17, 2005
FUEL SYSTEM, GASOLINE,EQUIPMENT
1 complaint
HELLO EVERYONE! WELL UNFORTANTELY I'M ALSO HAVING PROBLEMS WITH MY 2004 KIA SORENTO. I PURCHASED MY KIA FROM GEWEKE KIA IN LODI, CA ON SUPER BOWL SUNDAY (FEB. 1, 04). MY FIRST VISIT FOR MY KIA WAS ON FEB. 16TH TO INVESTIGATE WHY I HAD PROBLEMS STARTING MY KIA. I HAD TO KEEP CRANKING IT UNTIL IT WOULD TURN ON THIS WOULD HAPPEN WHEN THE CAR WOULD SIT FOR AWHILE SO BASICALLY IT WAS COLD EACH TIME I TRIED TURNING IT ON. WELL GEWEKE ORDER THE FUEL PUMP FOR THE KIA. THEY WERE INFORMED BY KIA TECH THAT WHAT NEEDED TO BE REPLACED WAS THE FUEL PUMP. WELL AFTER I GOT MY CAR BACK IT WORKED FINE FOR A FEWS WEEKS. THEN AGAIN IN JUNE OR JULY I HAD TO TAKE IT BACK IN BECAUSE I WAS GETTING THE SAME ISSUE WITH THE KIA. GEWEKE REPLACED THE FUEL PUMP ONCE AGAIN. WELL IT WORK GOOD FOR ANOTHER COUPLE OF WEEKS UNTIL THIS WEEKEND. I CALLED GEWEKE ON TUESDAY 9/7 SO I HAD TO LEAVE WORK EARLY AGAIN. THIS TIME GEWEKE PROVIDED ME WITH A RENTAL AND THEY ARE KEEPING MY CAR IN THEIR SHOP FOR A COUPLE OF DAYS. I CALLED THE SERVICE MANAGER AT GEWEKE AND HE INFORMED ME THAT HE HAS BEEN TRYING TO CONTACT KIA AND HAS NOT BEEN ABLE TO REACH THEM. HE ALSO INFORMED ME THAT HIS TECHNICIANS WON'T BE WORKING THIS FRIDAY AND SATURDAY AND THAT TOMORROW I WILL HAVE TO RETURN THE RENTAL ANDM PICK UP MY KIA EVEN THOUGH IT MIGHT NOT BE FIXED. IF ITS NOT FIXED I WILL HAVE TO DROP OFF THE KIA AT THE SHOP AND GET ANOTHER RENTAL ON THEM. I AM REALLY UNHAPPY WITH MY KIA AND I'M NOT 100 % SATISIFIED. I PURCHASED THIS BRAND NEW VEHICLE FOR ONE REASON AND IT WAS BECUASE I WAS TRIED OF HAVING TO REPAIR MY VEHICLE. I'M THINKING OF FILING A CLAIM ON THE VEHICLE. I GOT STUCK WITH A LEMON. HOPEFULLY THEY CAN FIX TGHE CAR BUT I WILL STILL NOT BE SATISFIED. CAN ANYONE GIVE ME ANY ADVICE ON WHAT I NEED TO DO TO GET OUT OF THIS F***ED UP KIA?*AK
Sep 09, 2004
STEERING,SERVICE BRAKES, HYDRAULIC,POWER TRAIN
1 complaint
I HAVE 3 MAJOR FAILURES W/MY NEW KIA SORENTO '04 SINCE BUYING IT IN DEC '03 FROM PEAK KIA IN COLO.THE 1ST FAILURE, THE ANTI LOCK BRAKE CONTROL UNIT WAS REPLACED IN DEC '03.THE BRAKES ENGAGED WHEN THEY SHOULDN'T. I HAVE COMPLAINED MANY TIMES ABOUT A ROAD VIBRATION AT 68-72 MPH. DEALER HAS SEEN MY CAR 5 TIMES FOR THIS PROBLEM. THE 1ST TIME THE DEALER SAID THEY COULDN'T FIND ANYTHING WRONG, BUT SAID THEY HAD ONLY DRIVEN IT TO 63 MPH. THE 2ND TIME I TOOK IT IN, PROBLEM HAD BEEN NOTED IN A NUMBER OF SORENTO'S NATIONWIDE & THEY WERE GOING TO NEED TO CHANGE THE DRIVE SHAFT. 3RD TIME FOR THIS SAME PROBLEM & UPON PICKING UP THE CAR FOUND OUT THAT THEY DIDN'T CHANGE THE DRIVE SHAFT, BUT GREASED IT W/SPECIAL HEAVY DUTY GREASE &TURNED IT 180 DEGREES. I ASKED WHY HADN'T CHANGED DRIVE SHAFT, & THEY SAID THE MANUFACTURER'S TECHNICAL SERVICE BULLETIN RECOMMENDED THIS PROCEDURE 1ST. THE VIBRATION HAS SLOWLY RETURNED. I CALLED THE DEALER & THEY SAID THEY WOULD PUT ME ON LIST TO DRIVE CAR W/REGIONAL SERVICE MGR. THEY CALLED & SAID HE WAS IN TOWN, SO I WENT TO DRIVE CAR WITH LOCAL SERVICE MGR & REGIONAL SERVICE MGR.THEY FELT THERE WAS NOTHING HIGHLY NOTICEABLE ABOUT VIBRATION & SAID IT COULD BE THE ROADS. THEY TOLD ME TO CALL BACK IF IT GOT WORSE. IN AUGUST '04, WERE DRIVING & MY CAR BEGAN TO SMOKE. A HUGE TRAIL OF SMOKE COMING OUT FROM UNDER CAR. WE PULLED TO THE SIDE OF THE ROAD & CALLED 24HR TOWING FROM THE DEALER. CAR TOWED TO OSBORN KIA IN COLO. & FOUND THAT THE ENTIRE RACK & PINON STEERING MECHANISM & GEAR BOX HAD BLOWN UP THROWING STEERING FLUID ON THE ENGINE. SO MUCH SMOKE I THOUGHT THE CAR WAS ON FIRE! WHAT COULD HAVE HAPPENED IF OUR STEERING WOULD HAVE GONE OUT IN A TIGHT TURN! THE DEALER'S SERVICE MGR SAID IN ALL OF HIS YEAR'S THE DEALERSHIP HAD NEVER REPLACED THIS PART. THE ENTIRE STEERING SYSTEM REPLACED, THE CAR IS NOW VIBRATING ONCE AGAIN AT 68-71MPH. I AM GOING TO CONTACT THE DEALER BUT AM CONCERNED THEY WILL NOT DO ANYTHING TO FIX THIS. *JB
Sep 05, 2004
Frequently Asked Questions
How many problems does the 2004 KIA Sorento have?
The 2004 KIA Sorento currently has 220 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.
What are the most common problems with 2004 KIA Sorento?
The most common problems reported for the 2004 KIA Sorento are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.
Where does this 2004 KIA Sorento problem data come from?
All problem and complaint data for the 2004 KIA Sorento comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.
Other Years - KIA Sorento
2005 Problems
2003 Problems
2002 Problems
2001 Problems
2000 Problems
1999 Problems
1998 Problems
1997 Problems
1996 Problems
1995 Problems
Other KIA Models
Similar Brands
ST
3,555 models
RS
3,484 models
NC
2,822 models
ND
2,385 models
Z
1,951 models
MOTO
1,583 models
NU
1,189 models
RC
1,122 models